text
stringlengths 595
18.7k
| label
int64 0
1
| label_text
stringclasses 2
values |
|---|---|---|
===================== Product Identification =====================
Product ID:MODIFIED OXIDES OF NITROGEN-I (MON-I)
Preparer's Name:DAVID GREEN
CAGE:GO313
CAGE:1K447
CAGE:GO313
============= Composition/Information on Ingredients =============
Ingred Name:NITROGEN TETROXIDE
CAS:10544-72-6
RTECS #:QX1575000
Fraction by Wt: 99-99.4%
OSHA PEL:1 PPM
ACGIH TLV:3 PPM
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:NITROUS OXIDE, NITROGEN OXIDE, NITROGEN MONOXIDE
CAS:10024-97-2
RTECS #:QX1350000
Fraction by Wt: 0.6-1%
Other REC Limits:50 PPM
OSHA PEL:25 PPM
ACGIH TLV:1050 MG/CUM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INGESTION: HIGH TOXICITY, HIGHLY
CORROSIVE TO TISSUE, TOXIC & MAY BE FATAL. EYES: IRRITATION, HIGHLY
CORROSIVE. SKIN: HIGHLY CORROSIVE, SERIOUS BURNS, & YELLOW
STAINING. INHALATION: HIGHLY CORROSIVE, BURNS TO TISSUE, PULMONARY
TRACT. CORROSIVE TO TEETH. MUCOUS MEMBRANE IRRITANT. HIGHLY TOXIC.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INGESTION: FATAL. EYES: PERMANENT INJURY.
INHALATION: PULMONARY & EDEMA DAMAGE, FATAL.
Medical Cond Aggravated by Exposure:EMPHYSEMA
======================= First Aid Measures =======================
First Aid:INGESTION: GIVE PLENTY OF WATER. DON'T INDUCE VOMITING. EYES:
FLUSH W/PLENTY OF WATER FOR AT LEAST 30 MINS. SKIN: WASH W/SOAP &
WATER FOR AT LEAST 15 MINS. INHALATION: REMOVE TO FRESH AIR.
ADMINISTERARTIFICIAL RESPIRATION IF BREATHING STOPS. OBTAIN
MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Fire Fighting Procedures:WEAR SELF-CONTAINED AIR SUPPLY & RESISTANT
CLOTHING.
Unusual Fire/Explosion Hazard:POWERFUL OXIDIZER. WILL INCREASE
INTENSITY OF FIRE THOUGH IT IS NOT FLAMMABLE ITSELF. MAY INCREASE
RISK OF EXPLOSION.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE PERSONNEL UPWIND. USE PROPER SAFETY
EQUIPMENT. CONTAIN MATERIAL. FLUSH W/WATER & NEUTRALIZE. KEEP OUT
OF LAKES OR STREAMS. NEUTRALIZE LIQUID RESIDUE W/DILUTE INORGANIC
BASE SOLUTION & DISPOSE .
Neutralizing Agent:SODIUM CARBONATE, LIME, OR SODIUM HYDROXIDE
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTACT W/SKIN, CLOTHING, EYES.
Other Precautions:AVOID BREATHING DUSTS. AVOID CONTACT W/WATER, BASES
OR ORGANIC MATERIAL. KEEP OUT OR REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR SELF-CONTAINED AIR SUPPLY OR FULL FACE
RESPIRATOR.
Ventilation:REQUIRED
Other Protective Equipment:ACID RESISTANT CLOTHING
Work Hygienic Practices:SHOWER AFTER HANDLING. REMOVE/LAUNDER CLOTHING
BEFORE REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:G7
Boiling Pt:B.P. Text:70F
Melt/Freeze Pt:M.P/F.P Text:11.8F
Vapor Pres:17.7
Vapor Density:1.58
Spec Gravity:1.49
Solubility in Water:COMPLETE
Appearance and Odor:GREENISH BROWN LIQUID W/ACIDIC ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
BASES, MOST METALS & ORGANICS, WATER
Stability Condition to Avoid:MOISTURE
Hazardous Decomposition Products:NOXIOUS FUMES, OXIDES OF NITROGEN
==================== Disposal Considerations ====================
Waste Disposal Methods:PRODUCT WILL EVAPORATE IF TEMPERATURE IS ABOVE
70F. DISPOSE OF AWAY FROM STREAMS & WATER IN ACCORDANCE W/FEDERAL,
STATE & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:PERM-SLIK 1460W (PPS1460W)
Preparer's Name:CHEMICAL COMMUNICATION
CAGE:8F024
CAGE:8F024
Contract Num:SP0450-01-M-LM70
CAGE:0PGK2
============= Composition/Information on Ingredients =============
Ingred Name:HEXADECANOL
CAS:36653-82-4
RTECS #:MM0225000
Minumum % Wt:5.
Maxumum % Wt:15.
Ingred Name:MORPHOLINE
CAS:110-91-8
RTECS #:QD6475000
Minumum % Wt:1.
Maxumum % Wt:5.
OSHA PEL:70 MG/M3;20 PPM
OSHA STEL:105 MG/M3
ACGIH TLV:71 MG/M3;20 PPM
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Minumum % Wt:80.
Maxumum % Wt:90.
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: CAN CAUSE IRRITATION, REDNESS,
BLURRED VISION. SKIN: PROLONGED CONTACT CAN CAUSE IRRITATION,
DERMATITIS. INHALATION: CAN CAUSE IRRITATION, DIZZINESS, NAUSEA,
FATIGUE, HEADACHE AND UNCONSCIOUSNES S OR ASPHYXIATION. INGESTION:
CAN CAUSE GASTROINTESTINAL IRRITATION, NAUSEA, VOMITING, AND
DIARRHEA.
Effects of Overexposure:EYES: IRRITATION, REDNESS, BLURRED VISION.
SKIN: IRRITATION, DERMATITIS. INHALATION: IRRITATION, DIZZINESS,
NAUSEA, FATIGUE, HEADACHE, AND UNCONSCIOUSNESS OR ASPHYXIATION.
INGESTION:GASTROINTESTINAL IRRITATION, NAUSEA, VOMITING, AND
DIARRHEA.
======================= First Aid Measures =======================
First Aid:SKIN: WASH WITH SOAP AND WATER. EYES: FLUSH WITH COPIOUS
AMOUNTS OF WATER, GET MEDICAL ATTENTION. INHALATION: REMOVE TO
FRESH AIR. IF BREATHING IS IMPAIRED, GET MEDICAL ATTENTION.
INGESTION: DO NOT IN DUCE VOMITING, KEEP WARM, GET MEDICAL
ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:WATER BASED
Lower Limits:N/D
Upper Limits:N/D
Extinguishing Media:NOT APPLICABLE.
Fire Fighting Procedures:NOT APPLICABLE.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN SPILL WITH ABSORBENT MATERIAL. FLUSH
WITH LARGE QUANTITIES OF WATER INTO INDUSTRIAL SEWER. CONSULT
LOCAL, STATE AND FEDERAL AUTHORITIES.
======================Handling and Storage ======================
Handling and Storage Precautions:PROTECT FROM PHYSICAL DAMAGE. STORE IN
A COOL, DRY, VENTILATED AREA AWAY FROM ACIDS, ALKALIS AND OPEN
FLAMES.
Other Precautions:NONE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED ORGANIC RESPIRATOR IF TWA/TLV
LIMITS ARE EXCEEDED.
Ventilation:LOCAL EXHAUST: USE TO MAINTAIN LEVELS BELOW TWA LIMITS.
MECHANICAL: USE NON-SPARKING EQUIPMENT.
Other Protective Equipment:NONE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:=100.C, 212.F
B.P. Text:212F - 220F
Melt/Freeze Pt:M.P/F.P Text:NOT AVAILABLE
Vapor Pres:NOT AVAILABLE
Spec Gravity:DENSITY+ 8.2 LB/GAL
VOC Pounds/Gallon:109
Evaporation Rate & Reference:NOT AVAILABLE
Solubility in Water:COMPLETE
Appearance and Odor:MILKY
=================== Toxicological Information===================
Toxicological Information:HEXADECANOL (CAS # 36653-82-4) IS A MILD SKIN
AND EYE IRRITANT. THE ORAL LD50, (ALBINO RATS) IS GREATER THAN 8.0
G KG. RATS EXPOSED TO 3.2 MG/L FOR 8 HOURS / DAY FOR 10 DAYS SHOWED
ONLY HYPER ACTIVITY . CACINOGENICITY: NTP-NO; IARC-NO; OSHA-NO. THE
VAPOR FROM MORPHOLINE (CAS # 110-91-8) CAN SEVERE SKIN AND EYE
IRRITATION AND IN SOME CASES BURNS. CHRONIC EXPOSURE: THIS
MORPHOLINE HAS BEEN FOUND TO C AUSE LIVER ABNORMALITIES, KIDNEY
DAMAGE AND EYE DAMAGE IN LABORATORY ANIMALS WITH CHRONIC OVER
EXPOSURE. CARCINOGENICITY: NTP - NO; IARC- NO; OSHA - NO.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF WATER IN A CHEMICAL LANDFILL AS
APPROVED BY CURRENT LOCAL, STATE AND FEDERAL LAWS AND REGULATIONS.
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:TPC SOLVENT AEROSOL
CAGE:56881
CAGE:56881
CAGE:56883
============= Composition/Information on Ingredients =============
Ingred Name:ISOPARAFFINIC HYDROCARBONS (NAPHTHA PETROLEUM),
HYDROTREATED HEAVY, NON AROMATIC HEAVY NAPHTHA) ISOPAR G *93-4*
CAS:64742-48-9
ACGIH TLV:300 PPM
Ingred Name:CARBON DIOXIDE
CAS:124-38-9
RTECS #:FF6400000
Other REC Limits:10000 PPM
OSHA PEL:5000 PPM
ACGIH TLV:9000 MG/CUM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:HIGH VAPOR CONCENTRATIONS (>1000 PPM)
ARE IRRITATING TO THE EYES, SKIN & RESPIRATORY TRACT. ASPIRATION
HAZARD; MAY BE FATAL. CENTRAL NERVOUS SYSTEM EFFECTS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:HIGH CONCENTRATIONS: HEADACHES, DIZZINESS, ARE
ANESTHESIA, COUGHING, DROWSINESS. ASPIRATION MAY CAUSE SEVERE
PULMONARY INJURY & POSSIBLE DEATH. EYES & SKIN: REDNESS.
Medical Cond Aggravated by Exposure:CUTS, ABRASIONS, DERMATITIS,
RESPIRATORY AILMENTS.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR 15 MINS. SKIN: REMOVE CONTAMINATED
CLOTHING. WASH W/SOAP & WATER. INHALATION: REMOVE TO FRESH AIR.
GIVE OXYGEN & CPR IF NECESSARY. INGESTION: DON'T INDUCE VOMITING.
OBTAIN MEDI CAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:130F
Lower Limits:0.7%
Upper Limits:7%
Extinguishing Media:FOAM, WATER SPRAY (FOG), DRY CHEMICAL
Fire Fighting Procedures:WEAR AIR-SUPPLIED BREATHING EQUIPMENT FOR
ENCLOSED AREAS. COOL CONTAINERS W/WATER SPRAY. AVOID BREATHING
VAPORS/FUMES.
Unusual Fire/Explosion Hazard:CONTENTS UNDER PRESSURE. CONTAINERS CAN
RUPTURE & EXPLODE IN AREA OF FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE IGNITION SOURCES. DIKE SPILL. RECOVER
FREE LIQUID. USE ABSORBENTS. VENTILATE AREA.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS CLOSED WHEN NOT IN
USE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:ORGANIC VAPOR MASK WHEN LEVELS EXCEED TLV.
Ventilation:MECHANICAL FOR ENCLOSED AREAS.
Other Protective Equipment:BOOTS, APRON, GAUNTLETS. EYE BATH & SHOWER
IN AREA.
Work Hygienic Practices:REMOVE & LAUNDER CONTAMINATED CLOTHING BEFORE
RE-USE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:345-386F
Vapor Pres:<10
Vapor Density:>5
Spec Gravity:0.760
Evaporation Rate & Reference:(N BU AC = 1): 0.1
Solubility in Water:INSOLUBLE
Appearance and Odor:CLEAR WATER WHITE LIQUID, VIRTUALLY ODORLESS
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDANTS
Stability Condition to Avoid:HEAT, OPEN FLAMES, OTHER IGNITION SOURCES
Hazardous Decomposition Products:CO, CO2, SMOKE, SOOT
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE I/A/W LOCAL, STATE & FEDERAL
REGULATIONS. UN 1950.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:N-450-11 SOLVENT BLEND (NEW FORMULA)
CAGE:88112
CAGE:88112
============= Composition/Information on Ingredients =============
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 52%
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:VMSP NAPHTHA CAS NO. 64742-89-8
Fraction by Wt: 14.5%
ACGIH TLV:300 PPM
Ingred Name:LACTOL SPIRITS CAS NO. 64742-89-8
Fraction by Wt: 13.5%
ACGIH TLV:300 PPM (MFR)
Ingred Name:METHYL ISOBUTYL KETONE (SARA III)
CAS:108-10-1
RTECS #:SA9275000
Fraction by Wt: 20%
OSHA PEL:100 PPM/75 STEL
ACGIH TLV:50 PPM/75 STEL; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Effects of Overexposure:EYES:IRRIT.SKIN:IRRIT,DERMAT W/PRLNG/RPT
USE.INH:RESP TRACT IRRIT,ANESTH,CNS DEPRESS (SEE SUP DATA)
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/LG AMT OF WATER AT LEAST 15 MIN.CONSULT A
PHYSICIAN.SKIN:WASH THOROUGHLY W/SOAP & WATER. INH:REMOVE TO FRESH
AIR.IF BRTH STOPS,BEGIN ARTIF RESP & CONSULT A PHYSICIAN.INGEST:DO
NOT INDUCEVOMITING.CONSULT PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:28F SCC
Lower Limits:0.9
Upper Limits:8.0
Extinguishing Media:FOAM,CO*2, OR DRY CHEMICAL
Fire Fighting Procedures:WEAR SELF CONTAINED BREATHING APPARATUS &
PROTECTIVE CLOTHES
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB ON SUITABLE INERT MATERIAL. REMOVE ALL
SOURCES OF IGNITION.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP & STORE IN COOL,DRY PLACE AWAY
FROM SOURCES OF IGNITION. GROUND DURING TRANSFER.
Other Precautions:REPEATED AND PROLONGED OVEREXPOSURE MAY CAUSE BRAIN &
NERVOUS SYSTEM DAMAGE. CONCENTRATING & INHALING THE CONTENTS MAY BE
HARMFUL OR FATAL. MSDS PREP BY: SYLVAIN M HIRSTY, DIR OF R S D.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPRVD RESP. MFR RECM CARTRIDGE
RESP;CONSULT SAFETY/I.H
Ventilation:MECHANICAL
Other Protective Equipment:EYE WASH STATIONS & SAFETY SHOWER RECM.
EYES:CHEM GOG ALSO
Supplemental Safety and Health
EFFECTS OF OVEREXPOSURE:INGEST:MAY CAUSE LIVER AND/OR KIDNEY DAMAGE.
DATE OF PREP: DEC 11,1985
================== Physical/Chemical Properties ==================
HCC:F2
Vapor Density:>1.0
Spec Gravity:0.82
Evaporation Rate & Reference:<1.0 (ETHER = 1)
Solubility in Water:PARTIALLY
Appearance and Odor:COLORLESS,CLEAR LIQUID W/CHARACTERISTIC ODOR
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Stability Condition to Avoid:SPARKS,OPEN FLAMES OR HOT SURFACES.
Hazardous Decomposition Products:CARBON MONOXIDE AND DIOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IAW APPLICABLE LOCAL,STATE & FEDERAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:CAT, 1-COAT, TT-P-2756, 26231 P/C 03GY407CAT
Kit Part:Y
Preparer's Name:NORM GAUL
CAGE:5M511
CAGE:33461
CAGE:5M511
============= Composition/Information on Ingredients =============
Ingred Name:ALIPHATIC ISOCYANATE (VAPOR PRESSURE 0 MM HG)
CAS:28182-81-2
RTECS #:NQ9170000
Fraction by Wt: 45%
Other REC Limits:NONE RECOMMENDED
Ingred Name:HEXAMETHYLENE DIISOCYANATE (HDI) (FREE MONOMER <0.5% AS
TIME OF MFR, AFTER 3-6 MO, MAY RISE TO MAX OF 1.6%)
CAS:822-06-0
RTECS #:MO1740000
Fraction by Wt: 0.5-1.6%
Other REC Limits:MOBAY:0.02 PPM CEIL
ACGIH TLV:0.005 PPM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:C8&10 AROMATIC HYDROCARBON (VAPOR PRESSURE 3 MM HG @ 68F)
CAS:64742-95-6
Fraction by Wt: <5%
Other REC Limits:MFR PEL: 100 PPM
Ingred Name:N-BUTYL ACETATE (VAPOR PRESSURE 13 MM HG @ 68F)
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: <5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:150 PPM;STEL 200 PPM
ACGIH TLV:150 PPM;STEL 200 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ETHYL 3-ETHOXYPROPIONATE (VAPOR PRESSURE 0.7 MM HG @ 68F)
CAS:763-69-9
RTECS #:UF3325000
Fraction by Wt: 10%
Other REC Limits:50 PPM; STEL 100 PPM
Ingred Name:METHYL ISOBUTYL KETONE (SARA III) (VAPOR PRESSURE 15 MM HG
@ 68F)
CAS:108-10-1
RTECS #:SA9275000
Fraction by Wt: 21.43%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:50 PPM; STEL 75 PPM
ACGIH TLV:50 PPM; STEL 75 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:CYCLOHEXANONE (VAPOR PRESSURE 3.4 MM HG @ 68F)
CAS:108-94-1
RTECS #:GW1050000
Fraction by Wt: 20%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:25 PPM
ACGIH TLV:25 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:VOC: 548 G/L
RTECS #:9999999VO
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL:RESP TRACT IRRIT
(HEADACHE,DIZZY,STAGGER,CONFUSION,UNCONSCIOUS,COMA).
SKIN:ISOCYANATES REACT W/SKIN PROTEIN & MOISTURE.IRRIT
(SWELL,RED,RASH).ABSORPTN:IRRIT (DRY,DEFAT,SKIN CRACK). EYES:IRRIT
(T EAR,RED,SWELL W/STING). INGEST:IRRIT, CORROSIVE IN GI
TRACT.VOMITING MAY CAUSE ASPIRATION,RESULTING IN CHEM PNEUMONITIS.
Effects of Overexposure:ACUTE: VAPORS ARE IRRITATING TO EYES, NOSE, &
THROAT. INHALATION MAY CAUSE HEADACHES, DIFFICULT BREATHING &
UNCONSCIOUSNESS. CHRONIC: AS RESULT OF PREVIOUS REPEATED
OVEREXPOSURE OR SINGLE LARGE DOSE,CERTAIN INDIVIDUALS WILL
DEVELOP ISOCYANATE SENSITIZATION (REACT TO LATER EXPOSURE OF
ISOCYANATE LEVELS BELOW TLV).
Medical Cond Aggravated by Exposure:ASTHMA AND ANY OTHER RESPIRATORY
DISORDERS. SKIN ALLERGIES, ECZEMA, AND DERMATITIS. ISOCYANATE
SENSITIZATION.
======================= First Aid Measures =======================
First Aid:INHAL:MOVE TO FRESH AIR.RESTORE BREATHING.ASTHMATIC TYPE
SYMPTOMS MAY DEVELOP (IMMEDIATE/DELAYED BY SEVERAL HRS).GET MEDICAL
AID. SKIN:REMOVE CONTAMINATED CLOTHING.WASH AFFECTED AREAS W/SOAP &
WATER.W ASH CONTAMINATED CLOTHING BEFORE REUSE.EYES:FLUSH
W/LUKEWARM WATER (LOW PRESSURE) 15 MIN,LIFT EYELIDS.GET MED AID.
INGEST:DON'T INDUCE VOMITING.DON'T GIVE ANYTHING TO UNCONSCIOUS
PERSON.GET MED AID.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:60.0F,15.6C
Lower Limits:1.00
Upper Limits:9.40
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG,
WATER SPRAY
Fire Fighting Procedures:USE FULL PROTECT CLOTH/FIREFIGHT EQUIP W/SCBA.
WATER MAY BE USED TO COOL CLSD CNTNRS (PREVENT PRESS
BLDUP/AUTOIGNIT/EXPLOS). HDI/IRRIT VAPOR GENERATED BY FIRE.
Unusual Fire/Explosion Hazard:KEEP CNTNR CLSD. KEEP FROM HEAT/IGNIT
SOURCE. CLSD CNTNR MAY EXPLODE W/HEAT. APPLIC TO HOT SURFACE REQ
SPECIAL PRECAUTION. OVEREXPOSURE TO DECOMP PROD-HLTH HZD.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE ALL NON-ESSENTIAL PERSONNEL. REMOVE
ALL SOURCES OF IGNITION (FLAME, SPARK SOURCES, HOT SURFACES).
VENTILATE AREA. CONTAIN & REMOVE WITH INERT ABSORBENT AND
NON-SPARKING TOOLS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN BLDG IN COMPLY W/OSHA
1910.106,IN TIGHT CLOSD CNTNR IN VENTD AREA.AVOID STORING NEAR HIGH
TEMP/IGNIT SOURCE.PREVENT PROLONGED VAPOR BREATHING
Other Precautions:KEEP CONTAINERS TIGHT & UPRIGHT (PREVENT LEAK).
PROLONGED OVEREXPOSURE MAY CAUSE ALLERGIC REACTION. AVOID CONTACT
WITH SKIN & EYES. DO NOT INGEST. DO NOT HANDLE TILL MFR'S
PRECAUTIONS READ OR UNDERSTO OD. SMOKE IN SMOKING AREAS ONLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESPIRATOR RECOMMENDED FOR USE IN ORGANIC VAPOR
ENVIRONMENT (AIR PURIFYING/AIR SUPPLIED).OBEY OSHA REGS FOR
RESPIRATOR. PROVIDE VENT TO KEEP EXPOSURE LEVELS BELOW OSHA LIMITS.
VAPOR PARTIC RESPIRATOR (TC23C) WHERE BELOW 10 TIMES TLV/PEL.
Ventilation:EXHAUST VENT TO KEEP AIRBORNE CONCENTRATION OF SOLVENT, HDI
& POLYISOCYANATES BELOW TLV. REMOVE IGNITION SOURCES.
Other Protective Equipment:THE USE OF LONG SLEEVE AND LONG LEG CLOTHING
IS RECOMMENDED. REMOVE AND WASH CONTAMINATED CLOTHING BEFORE REUSE.
Work Hygienic Practices:WASH HANDS BEFORE EATING, SMOKING, OR USING
WASHROOM.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:241 TO 338F
Vapor Density:> AIR
Spec Gravity:0.98679
Viscosity:*
Evaporation Rate & Reference:0.71 X N-BUTYL ACETATE
Solubility in Water:INSOLUBLE
Appearance and Odor:AMBER LIQUID WITH SOLVENT ODOR
Percent Volatiles by Volume:62.4
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER, AMINES, STRONG BASES, ALCOHOLS, METAL COMPOUNDS AND SURFACE
ACTIVE MATERIALS.
Stability Condition to Avoid:CONTACT WITH MOISTURE, MATERIAL WHICH
REACT WITH ISOCYANATES AND HIGH TEMPERATURES.
Hazardous Decomposition Products:BY HIGH HEAT/TEMPERATURE: CARBON
MONOXIDE, CARBON DIOXIDE, AND OXIDES OF NITROGEN, TRACES OF HCN AND
HDI.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE MUST BE DISPOSED OF IN ACCORDANCE
W/FEDERAL, STATE, & LOCAL ENVIRONMENTAL CONTROL REGULATIONS. EMPTY
CONTAINERS MUST BE HANDLED W/CARE, DUE TO PRODUCT RESIDUE &
FLAMMABLE VAPOR. DO NOT INCINERAT E CLOSED CONTAINERS. EPA HZD
CODE:D001,F003,F005.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:MIL-D-9063B REMOVER
Preparer's Name:NONE
CAGE:60777
CAGE:60777
============= Composition/Information on Ingredients =============
Ingred Name:DICHLOROMETHANE, (METHYLENE CHLORIDE) (SARA 313) (CERCLA)
CAS:75-09-2
RTECS #:PA8050000
Fraction by Wt: 80-85%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:500 PPM; Z-2
ACGIH TLV:50 PPM, A2; 9495
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:METHYL ALCOHOL (METHANOL) (SARA 313) (CERCLA)
CAS:67-56-1
RTECS #:PC1400000
Fraction by Wt: 10-15%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:S, 200 PPM
ACGIH TLV:S,200PPM/250STEL; 95
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ETHANOL,2 AMINE, (ETHANOLAMINE)
CAS:141-43-5
RTECS #:KJ5775000
Fraction by Wt: 0.1-2%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:3 PPM
ACGIH TLV:3 PPM/6 STEL; 9495
Ingred Name:PROPRIETARY
CAS:26264-05-1
Fraction by Wt: 0.1-2%
Other REC Limits:NONE RECOMMENDED
Ingred Name:NON HAZARDOUS COMPONENTS
Fraction by Wt: 0.1-2%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: EYES: IRRITATION. SKIN:
IRRITATION, DEFATTING, DERMATITIS. INHALATION: NASAL AND
RESPIRATORY IRRITATION, INCREASE IN CARBOXYHEMOGLOBIN, CNS EFFECTS,
UNCONSCIOUSNESS, ASPHYXIATION. INGESTION: GI TRACT IRRITATION,
NAUSEA, BLINDNESS, DEATH. CHRONIC: LIVER ABNORMALALITIES,
LUNG/KIDNEY/BRAIN/CNS DAMAGE.
Explanation of Carcinogenicity:METHYLENE CHLORIDE LISTED BY NTP AND
IARC, AND REGULATED BY OSHA.
Effects of Overexposure:EYES: IRRITATION, DAMAGE. SKIN: IRRITATION,
DEFATTING, DERMATITIS. INHALATION: NASAL AND RESPIRATORY TRACT
IRRITATION, INCREASE IN CARBOXYHEMOGLOBIN, LUNG DAMAGE, CNS
EFFECTS, DIZZINESS, NAUSEA, HEADA CHES, UNCONSCIOUSNESS,
ASPHYXIATION. INGESTION: GI TRACT IRRITATION, NAUSEA, BLINDNESS,
LIVER/KIDNEY/BRAIN/CNS DAMAGE.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH LARGE AMOUNTS OF WATER. GET MEDICAL
ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING. WASH AREA WITH SOAP
AND WATER AT LEAST 3 TIMES. INHALATION: MOVE TO FRESH AIR. IF NOT
BREATHING, GIV E CPR. IF BREATHING DIFFICULT, GIVE OXYGEN. GET
MEDICAL ATTENTION. INGESTION: IF CONSCIOUS GIVE ONE GLASS OF WATER.
GET MEDICAL ATTENTION. CONTACT POISON CONTROL CENTER.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:NONE TO BOILING
Extinguishing Media:WATER SPRAY, DRY CHEMICAL, CARBON DIOXIDE, FOAM.
WEAR SELF CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR AND MAY
TRAVEL TO A SOURCE OF IGNITION AND FLASH BACK.
================== Accidental Release Measures ==================
Spill Release Procedures:PICK UP SPILL ON NON-COMBUSTABLE ABSORBENT AND
PLACE IN COVERED CONTAINER FOR DISPOSAL. FLUSH AREA WITH WATER TO
REMOVE LAST TRACES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL VENTILATED AREA AWAY
FROM IGNITION SOURCES,ACIDS,OXIDIZERS. KEEP CONTAINERS TIGHTLY
CLOSED. STORAGE TEMPERATURES SHOULD NOT EXCEED 100F.
Other Precautions:NO SMOKING OR EATING IN HANDLING AREAS. EMPTY
CONTAINERS MAY BE HAZARDOUS. DO NOT CUT OPEN WITH IGNITION SOURCES.
MATERIAL ATTACKS GEL COATINGS AND FIBER GLASS BOARD.MISUSE BY
DELIBERATELY CONCENTRATI NG AND INHALING MAY BE HARMFUL OR FATAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF TLV IS EXCEEDED, A NIOSH/MSHA APPROVED AIR
SUPPLIED RESPIRATOR IS ADVISED IN THE ABSENCE OF PROPER
ENVIRONMENTAL CONTOL.
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL OR LOCAL EXHAUST)
VENTILATION FOR AREAS OF USE TO MAINTAIN EXPOSURE UNDER TLV'S.
Other Protective Equipment:PROVIDE EYE WASH STATION AND SAFETY SHOWER.
WEAR LONG SLEEVES, APRONS, OR OTHER PERSONAL CLOTHING PROTECTION AS
NEEDED.
Work Hygienic Practices:WASH AFTER HANDLING AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
AVOID CONTACT WITH THIS MATERIAL. DO NOT WEAR CONTACT LENSES, EAT, OR
SMOKE WHEN WORKING WITH THIS MATERIAL.
================== Physical/Chemical Properties ==================
HCC:T4
Boiling Pt:B.P. Text:93 T0 113F
Melt/Freeze Pt:M.P/F.P Text:-22F,-30C
Vapor Pres:<310
Vapor Density:2.5
Spec Gravity:1.21
pH:8.7
Evaporation Rate & Reference:.06 (BUTYL ACETATE=1)
Solubility in Water:PARTIALLY MISCIBLE
Appearance and Odor:CLEAR TO LIGHT AMBER LIQUID. METHYLENE CHLORIDE
ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, OXIDIZERS.
Stability Condition to Avoid:AVOID HIGH TEMPERATURES.
Hazardous Decomposition Products:COMBUSTION PRODUCES CARBON DIOXIDE AND
MONOXIDE,AMMONIA,NITROGEN OXIDES,HYDROGEN CHLORIDE,PHOSGENE,VARIOUS
HYDROCARBONS.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONSULT YOUR LOCAL, STATE AND FEDERAL
REGULATIONS ON PROPER METHODS OF DISPOSAL.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:1-(2-PYRIDYLAZO)-2-NAPHTHOL, P9506
CAGE:21076
CAGE:21076
============= Composition/Information on Ingredients =============
Ingred Name:1-(2-PYRIDYLAZO)-2-NAPHTHOL
CAS:85-85-8
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY BE HARMFUL BY INHALATION,
INGESTION, OR SKIN ABSORPTION. CAUSES EYE AND SKIN IRRITATION.
MATERIAL IS IRRITATING TO MUCOUS MEMBRANES AND UPPER RESPIRATORY
TRACT. TO THE BEST OF OUR KNOWLEDGE, THE C HEMICAL, PHYSICAL, AND
TOXICOLOGICAL PROPERTIES HAVE NOT BEEN THOROUGHLY INVESTIGATED.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: IMMED FLUSH WITH COPIOUS AMOUNTS OF WATER FOR AT LEAST
15 MIN. SKIN: IMMED WASH WITH SOAP AND WATER. INHAL: REMOVE TO
FRESH AIR. IF NOT BREATHING, GIVE ARTF RESP. IF BREATHING IS
DIFFICULT, GIVE O2. CALL PHYS. WASH CONTAMINATED CLOTHING BEFORE
REUSE. INGEST: CALL MD IMMED .
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER SPRAY. CARBON DIOXIDE, DRY CHEMICAL POWDER,
ALCOHOL OR POLYMER FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT TO PREVENT CONTACT WITH SKIN AND EYES.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR SCBA, RUBBER BOOTS AND HEAVY RUBBER
RAISING DUST. VENTILATE AREA AND WASH SPILL SITE AFTER MATERIAL
PICKUP IS COMPLETE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT GET IN EYES, ON SKIN, ON
CLOTHING. KEEP TIGHTLY CLOSED. STORE IN COOL DRY PLACE.
Other Precautions:AVOID CONTACT AND INHALATION. IRRITANT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:MECHANICAL EXHAUST REQUIRED.
Other Protective Equipment:SAFETY SHOWER AND EYE BATH.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:280F,138C
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
================= Stability and Reactivity Data =================
STRONG OXIDIZING AGENTS, STRONG BASES.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:TOXIC FUMES OF: CARBON MONOXIDE AND
CARBON DIOXIDE, NOX.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISSOLVE OR MIX MATERIAL WITH COMBUSTIBLE
SOLVENT AND BURN IN A CHEMICAL INCINERATOR EQUIPPED WITH AN
AFTERBURNER AND SCRUBBER. OBSERVE ALL FEDERAL, STATE, AND LOCAL
LAWS.
| 1 | eyes_protection_mandatory |
=======================================================
Product ID: ACRYLIC TRED-SAFE TINTING WHITE, 164-8415
Cage: 83571
Box: 8470
=======================================================
Contractor Summary
=======================================================
Cage: 83571
=======================================================
Ingredients
=======================================================
Cas: 13463-67-7
RTECS #: XR2275000
% Wt: <10
OSHA PEL: 15 MG/M3 TDUST
ACGIH TLV: 10 MG/M3 TDUST
------------------------------
Cas: 14808-60-7
RTECS #: VV7330000
% Wt: 15
OSHA PEL: 0.1 MG/M3 RDUST(MFR)
ACGIH TLV: 0.1 MG/M3 RDUST
------------------------------
Cas: 5131-66-8
RTECS #: UA7700000
% Wt: <5
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 14807-96-6
RTECS #: WW2710000
SILICATE)
% Wt: <15
OSHA PEL: 20 MPPCF
ACGIH TLV: 2 MG/M3 RDUST
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: YES
IARC: YES
OSHA: NO
Effects of Exposure: EYES:DIRECT CONTACT MAY RESULT IN IRRITATION.
SKIN:PROLONGED OR REPEATED CONTACT CAN CAUSE MODERATE IRRITATION.
INHAL:EXCESSIVE INHALATION OF SPRAY MIST MAY CAUSE IRRITATION OF MUCOUS
MEMBRANES OF NOS E, THROAT, RESPIRATORY TRACT & HEADACHE& NAUSEA.
LONG TERM OVEREXPOSURE TO TALC &/OR SILICA CAN CAUSE (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: SILICA, CRYSTALLINE-QUARTZ:IARC MONOGRAPHS,
SUPP, VOL 7, PG 341, 1987:GRP 2A. NTP 7TH ANNUAL RPT ON CARCINS, (SUPP DATA)
Signs And Symptions Of Overexposure: HLTH HAZ:SEVERE LUNG DAMAGE.
INGEST:SWALLOWING MAY CAUSE GASTROINTESTINAL IRRITATION, NAUSEA &
VOMITING.
Medical Cond Aggravated By Exposure: RESPIRATORY TRACT IRRITATION, DERMATITIS,
NAUSEA.
First Aid: INGEST:CALL MD IMMED (FP N). EYES:FLUSH W/LG AMTS OF WATER FOR AT
LST 15 MINS, LIFTING UPPER & LOWER LIDS OCCAS, GET MED ATTN IF IRRIT
PERSISTS. SKIN:WIPE OFF PAINT, THEN THORO WASH EXPOS AREA W/SOAP &
WATER. REMOVE & LAUNDER CONTAM CLTHG BEFORE RE-USE. INHAL:REMOVE
INDIVIDUAL TO FRESH AIR. IF BRTHG IS DFCLT, ADMIN OXYGEN. IF BRTHG HAS
STOPPED GIVE ARTF RESP. KEEP PERS WARM, QUIET & GET MED ATTN.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: SMALL SPILLS MAY BE ABSORBED ON PAPER, VERMICULITE,
FLOOR ABSORBENT, OTHER ABSORBENT MATERIALS. LARGE SPILLS SHOULD BE DIKED TO
CONTAIN MATERIAL & LIQUID PUMPED TO SALVAGE TANK.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DEPOSIT IN LANDFILL I/A/W ALL LOCAL, STATE &
FEDERAL REGULATIONS.
Handling And Storage Precautions: KEEP CLOSURES TIGHT & DRUMS UPRIGHT TO
PREVENT LEAKAGE. DO NOT STORE IN EXTREME HEAT OR ALLOW TO FREEZE.
Other Precautions: DUST OR PARTICLES RESULTING FROM SANDING, BLASTING OR
ABRADING DRY COATING WILL CONTAIN TALC, MICA & SILICA WHICH ARE
HAZARDOUS. WEAR A NIOSH/MSHA APPROVED RESPIRATOR.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: 158F,70C
Lower Limits: 1.1%
Extinguishing Media: FOAM, "ALCOHOL" FOAM, CO*2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures: USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N). A WATER STREAM MAY BE USED TO COOL CLOSED CONTAINERS TO
PREVENT EXCESSIVE PRESSURE BUILD-UP.
Unusual Fire/Explosion Hazard: COMBUST LIQ CLASS IIIA. THIS PROD WILL NOT
ORDINARILY SUSTAIN COMBUSTION, BUT MAY SPATTER IF TEMP EXCEEDS BOILING POINT.
EXTREME HEAT MAY CAUSE CLSD (SUPP DATA)
=======================================================
Control Measures
=======================================================
Respiratory Protection: WHEN SPRAYING THIS MATERIAL USE A NIOSH/MSHA APPROVED
RESPIRATOR.
Ventilation: SUFFICIENT GENERAL MECHANICAL VENTILATION OR LOCAL EXHAUST SHOULD
BE PROVIDED WHEN SPRAYING THIS MATERIAL.
Other Protective Equipment: EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET ANSI
DESIGN CRITERIA (FP N). APRON IF SPLASHING IS LIKELY.
Work Hygienic Practices: WASH HANDS BEFORE EATING, SMOKING OR USING THE
WASHROOM.
Supplemental Safety and Health: EXPLO HAZ:CONTAINERS TO EXPLODE FROM EXCESSIVE
STEAM PRESSURE. BURNING OF DRIED FILM WILL PRODUCE OXIDES OF CARBON &
NITROGEN. EXPLAN OF CARCIN:1994:ANTICIPATED TO BE CARCINOGEN.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: >212F,>100C
Vapor Pres: SEE ING 3
Vapor Density: HVR/AIR
Spec Gravity: 1.5 (FP N)
Evaporation Rate & Reference: SLOWER THAN ETHER
Appearance and Odor: NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume: 54-55
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: DO NOT STORE IN EXTREME HEAT OR ALLOW TO FREEZE.
Materials To Avoid: WILL REACT VIOLENTLY W/WATER SENSITIVE MATERIALS SUCH AS
SULFURIC ACID OR ALKALI MATLS SUCH AS SODIUM/METAL HYDRIDES.
Hazardous Decomposition Products: IF HEATED TO DECOMPOSITION WILL PRODUCE
OXIDES OF CARBON & NITROGEN.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: ACRYLIC TRED-SAFE TINTING WHITE, 164-8415
Cage: 83571
Company Name: HARRISON PAINT CORP
Street: 1323 HARRISON AVE SW
Zipcode: 44711
Label Required IND: Y
Date Of Label Review: 08/01/1995
Status Code: C
Label Date: 08/01/1995
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: Moderate
Reactivity Hazard: None
Hazard And Precautions: COMBUSTIBLE. ACUTE:EYES:DIRECT CONTACT MAY RESULT IN
IRRITATION. SKIN:PROLONGED OR REPEATED CONTACT CAN CAUSE MODERATE IRRITATION.
INHAL:EXCESSIVE INHALATION OF SPRAY MIST MAY CAUSE IRRITATION OF MUCO US
MEMBRANES OF NOSE, THROAT, RESPIRATORY TRACT & HEADACHE & NAUSEA.
LONG TERM OVEREXPOSURE TO TALC &/OR SILICA CAN CAUSE SEVERE LUNG DAMAGE.
INGEST:SWALLOWING MAY CAUSE GASTROINTESTINAL IRRITATION, N AUSEA &
VOMITING. CHRONIC:CANCER HAZARD. CONTAINS CRYSTALLINE SILICA WHICH IS LISTED
AS A LUNG CARCINOGEN (FP N).
=======================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:DIURON 4L HERBICIDE
Preparer's Name:MIKE SHANKLE
CAGE:2Z247
CAGE:2Z247
============= Composition/Information on Ingredients =============
Ingred Name:DIURON
CAS:330-54-1
RTECS #:YS8925000
Fraction by Wt: 40%
ACGIH TLV:10 MG/CUM
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:INERT INGREDIENTS
Fraction by Wt: 60%
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(RAT): 1,017 MG/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY IRRITATE EYES, NOSE, THROAT &
SKIN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:MAY IRRITATE EYES, NOSE, THROAT & SKIN.
======================= First Aid Measures =======================
First Aid:SKIN: WASH W/COPIOUS AMOUNTS OF SOAP & WATER. EYES: FLUSH
W/WATER FOR 15 MINS. INHALATION: REMOVE TO FRESH AIR. TREAT
SYMPTOMATICALLY & SUPPORTIVELY. INGESTION: DRINK 1-2 GLASSES OF
WATER & INDUCE VOM ITING. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:>200F
Extinguishing Media:DRY CHEMICAL, CO2, FOAM/WATER SPRAY
Fire Fighting Procedures:FIGHT FIRE FROM UPWIND. USE SELF CONTAINED
BREATHING APPARATUS. PREVENT RUN-OFF IF POSSIBLE.
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN UP PROMPTLY. DON'T FLUSH W/WATER, PICK
UP ABSORBENT/OTHER EFFECTIVE MEANS. ASSURE PROTECTIVE EQUIPMENT IS
WORN.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T STORE NEAR OPEN FLAME. KEEP OUT
OF REACH OF CHILDREN. KEEP AWAY FROM FOODSTUFFS.
Other Precautions:FOLLOW LABEL DIRECTIONS CAREFULLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NORMALLY NONE REQUIRED
Ventilation:RECOMMENDED IN CONFINED AREAS.
Other Protective Equipment:COVERALLS, LONG-SLEEVE SHIRT, RUBBER BOOTS
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>212F
Vapor Pres:NEGLIGIBLE
Spec Gravity:1.2
pH:6-7
Solubility in Water:DISPERSIBLE
Appearance and Odor:LIGHT TAN LIQUID W/NO ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:EXTREME TEMPERATURES
Hazardous Decomposition Products:TOXIC OXIDES OF NITROGEN & CARBON
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:POR CRAX FORMULA HP
CAGE:31662
CAGE:31622
CAGE:31662
============= Composition/Information on Ingredients =============
Ingred Name:ASPHALT (PETROLEUM)
CAS:8052-42-4
RTECS #:CI9900000
Fraction by Wt: 55-88%
ACGIH TLV:5 MG/M3; (FUME);9192
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 5-20%
Ingred Name:MINERAL FILLER
Fraction by Wt: 5-30%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN: MINIMAL IRRITATION. INHAL:
PROLONGED INHALATION OF VAPOR/MIST OF SUFFICIENT CONCENTRATION MAY
CAUSE INTERFERENCE WITH RESPIRATORY FUNCTIONS. INGEST: PRODUCT HAS
LOW ORDER OF ACUTE TOXICITY AND MAY CAUSE GASTROINTESTINAL
IRRITATION, NAUSEA, VOMITING AND DIARRHEA.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:ITCHING OR BURNING EYES OR SKIN, INHALATION,
DIZZINESS AND/OR SHORTNESS OF BREATH.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR AT LEAST 15 MIN, CONTACT PHYS.
SKIN: WASH WITH SOAP AND WATER. IF REDNESS OR ITCHING PERSISTS,
CONTACT PHYS. INHAL: REMOVE TO FRESH AIR AND OBTAIN MED ATTN IF
RESPIRATORY FU NCTIONS ARE IMPAIRED. INGEST: DO NOT INDUCE
VOMITING, CONTACT PHYS.
===================== Fire Fighting Measures =====================
Flash Point Method:TOC
Flash Point:>300F,>149C
Extinguishing Media:CARBON DIOXIDE, FOAM, DRY CHEMICAL AND WATER FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT. AVOID USING WATER STREAM TO PVNT FROTHING.
USE WATER SPRAY TO COOL EXPOSED SURFACES.
Unusual Fire/Explosion Hazard:NEVER USE WELD/CUTTING TORCH ON/NEAR
DRUM(EVEN EMPTY) BECAUSE PROD(EVEN RESIDUE) CAN IGNITE EXPLOS. CO &
OTHER ORG CMPD MAY BE FORMED UPON COMBUSTION.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL SPILL: WIPE UP MATERIAL WITH ABSORBANT
MATERIAL. USE SOAP AND WATER IMMED FOR EASY CLEANUP. LARGE SPILL:
CONTAIN SPILLED MATL WITH SAND, AGGREGATE OR OTHER ABSORBANT AND
SHOVEL MATERIAL INTO CON TR. WEAR PROT CLTHG DURING CLEANUP.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP MATL ABOVE FREEZING. DO NOT STORE
OVER 6 MONTHS. STORE IN COOL/DRY/WELL-VENTD AREA. DO NOT TAKE
INTERNALLY. DISPOSE OF USED CONTR (SUPDAT)
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NEEDED UNLESS USED IN CONFINED AREA.
Ventilation:LOCAL EXHAUST: ADEQUATE. MECHANICAL(GENERAL): NONE NEEDED.
Other Protective Equipment:NONE NEEDED.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. REMOVE
CONTAMINATED CLOTHING AND LAUNDER BEFORE REUSE.
Supplemental Safety and Health
HNDLG/STOR PREC: PROPERLY ACCORDING TO LOCAL, STATE AND FEDERAL
REGULATIONS.
================== Physical/Chemical Properties ==================
HCC:B3
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:<20
Vapor Density:>AIR
Spec Gravity:1.06@77F
pH:10.9
Evaporation Rate & Reference:<ETHER(BUTYL ACETATE=1)
Solubility in Water:COMPLETELY
Appearance and Odor:DARK BROWNISH GREY VISCOUS LIQUID WITH ASPHALT
PETROLEUM ODOR.
Percent Volatiles by Volume:30
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH WATER, ACIDS, PETROLEUM, SOLVENTS AND SOAPS.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:THERMAL DECOMPOSITON MAY PRODUCE
CARBON MONOXIDE AND OTHER UNKNOWN ORGANIC COMPOUNDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:SMALL SPILL: PLACE IN AN APPROVED LANDFILL
ACCORDING TO LOCAL, STATE AND FEDERAL REGULATIONS. LARGE SPILL:
CLOSE CONTAINER AND DEPOSIT IN AN APPROVED LANDFILL ACCORDING TO
LOCAL, STATE AND FEDERAL REG ULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:360LF LIQUID FOAM
CAGE:3R434
CAGE:3R434
============= Composition/Information on Ingredients =============
Ingred Name:FIBERS, REFRACTORY CERAMIC
RTECS #:LK3628000
Fraction by Wt: 100%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CURRENTLY, THERE ARE NO KNOWN CHRONIC
HLTH EFTS IN HUMANS FROM LONG TERM EXPOS TO REFRACTORY CERAMIC
FIBERS. ANIMAL STUDIES TO DATE ARE INCONCLUSIVE. HOWEVER, BASED ON
LTD TESTING, REFRACTORY CERAMIC FIBERS ARE SUSPECTED CARCIN IN LAB
ANIMALS. THERMAL INSULATION MFR'S ASSOC (TIMA) IS SPONSORING ANIMAL
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:INHAL STUDIES AS WELL AS
EPIDEMIOLOGICAL STUDIES OF WORKERS IN INDUSTRY. UNTIL DEFINITE
ANSWERS BECOME AVAIL, STRICT ADHERENCE TO REC SAFE WORK PRACTICES
DESCRIBED ELSEWHERE IN THIS MSDS IS A DVISED. THIS PROD CONTAINS
MINOR AMTS OF BINDERS WHICH BURN OUT DURING FIRST HEAT UP. THIS
PROD AS MFRD IS AN (SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:TERMINATE EXPOSURE. INGEST:CALL MD IMMEDIATELY . INHAL:REMOVE
TO FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTF RESP) .
EYES:IMMEDIATELY FLUSH W/POTABLE WATER FOR A MINIMUM OF 15 MINUTES,
SEE K ASSISTANCE FROM MD . SKIN:FLUSHW/COPIOUS AMOUNTS OF WATER.
CALL MD .
===================== Fire Fighting Measures =====================
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
================== Accidental Release Measures ==================
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:DUST RESPIRATOR IN COMPLIANCE W/OSHA STANDARD
CURRENTLY 29 CFR 1910.134 (NIOSH/MSHA APPROVED AIR PURIFYING, HALF
MASK OR FULL FACEPIECE RESPIRATOR W/APPROPRIATE FILTER PAD OR
CARTRIDGE(S).
Ventilation:LOCAL EXHAUST &/OR MECHANICAL (GENERAL): FOLLOW OSHA
STANDARD 29 CFR 1910.134.
Other Protective Equipment:LONG SLEEVE, LOOSE FITTING CLOTHING &
BARRIER CREAM.
Work Hygienic Practices:ROUTINE HOUSEKEEPING.
Supplemental Safety and Health
EFTS OF OVEREXP:ALUMINOSILICATE WHICH COULD TRANSFORM UPON HEATING TO
MULLITE & CRISTOBALITE (FORM OF CRYSTALLINE SILICA). REMOVAL OF
THIS PROD AFTER USE MAY RSLT IN GENERATION OF DUST. RPTD INHAL OF
RESPIRABLE FREE CRYSTALLINE SILICA DUSTMAY CAUSE DELAYED LUNG
INJURY (SILICOSIS).
================== Physical/Chemical Properties ==================
Spec Gravity:0.2-1.2(H*2O=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:FIBER SHAPE; NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS .
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:SILICA GEL
CAGE:16210
CAGE:00334
CAGE:16210
============= Composition/Information on Ingredients =============
Ingred Name:SILICA, AMORPHOUS, PRECIPITATED AND GEL
CAS:7699-41-4
RTECS #:VV8850000
Fraction by Wt: UNKN
OSHA PEL:20 MPPCF
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:WATER(AS ABSORBED MOISTURE)
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: UNKN
===================== Hazards Identification =====================
LD50 LC50 Mixture:1-HOUR LC50 (RAT) >2 MG/L
Effects of Overexposure:IRRIT OF MUCOUS MEMBRANES OF NOSE/THROAT &
IRRIT OF SKIN
======================= First Aid Measures =======================
First Aid:WASH DUST FROM SKIN/EYES W/WATER. IF SWALLOWED, DRINK PLENTY
WATER IMMED. MATL WILL PASS THROUGH BODY NORMALLY.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP OR VACUUM UP OR FLUSH TO APPRVD STORAGE
CNTNR
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP TIGHTLY SEALED TO PROTECT QUALITY
Other Precautions:AVOID INHALATION OF DUST.TLV FOR RESPIRABLE DUST IS 5
RESPIRATOR FOR DUST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR FOR DUST.
Ventilation:PROVIDE MECHAN(GEN/LOCAL EXHAUST)VENT TO MAINTN <TLV
Other Protective Equipment:AS REQUIRED TO PREVENT PROLONGED CONTACT.
Supplemental Safety and Health
MSDS DATED SEPT. 11,1984
================== Physical/Chemical Properties ==================
HCC:N1
Vapor Pres:UNK
Vapor Density:UNKN
Spec Gravity:2.1
Solubility in Water:INSOLUBLE
Appearance and Odor:DRY WHITE GRANULES, PARTICLE SIZE 200 MESH -3 MESH
Percent Volatiles by Volume:UNKN
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
HF
==================== Disposal Considerations ====================
Waste Disposal Methods:BURY OR COVER IT IN AN APPRVD LANDFILL IN
ACCORDANCE WITH LOCAL,STATE & FEDERAL REGULATIONS.COVER PROMPTLY TO
AVOID BLOWING OF DUST.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:FRANCO A
CAGE:07316
CAGE:07316
CAGE:7A143
============= Composition/Information on Ingredients =============
Ingred Name:ALPHA-ALUMINA (ALUMINUM OXIDE) (SARA 313)
CAS:1344-28-1
RTECS #:BD1200000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9596
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:SEE TABLE Z-3
ACGIH TLV:0.1 MG/M3 RDUST;9596
Ingred Name:SILICA, CRYSTALLINE - CRISTOBALITE
CAS:14464-46-1
RTECS #:VV7325000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:SEE TABLE Z-3
ACGIH TLV:0.05 MG/M3 RDUST9596
Ingred Name:SILICA, CRYSTALLINE - FUSED
CAS:60676-86-0
RTECS #:VV7328000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:SEE TABLE Z-3
ACGIH TLV:0.1 MG/M3 RDUST;9596
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:AS MANUFACTURED, POSES NO SIGNIFICANT
HAZARD. PARTICULATES FORMED DURING PROCESSING MAY CAUSE: EYES-
SLIGHT TO MODERATE IRRITATION. SKIN- SLIGHT IRRITATION. INHLATION-
SLIGHT TO MODERATE IRRITATION OF MUCOUS MEMBRANES. INGESTION-
UNLIKELY.IF HAPPENS, MAY CAUSE GASTROINTESTINAL DISTURBNCES.
CHRONIC: SILICOSIS.
Explanation of Carcinogenicity:IARC- CRYSTALLINE SILICA, GROUP 1
CARCINOGEN. NTP- CRYSTLLINE SILICA AS REASONABLY ANTICIPATED TO BE
A CARCINOGEN.
Effects of Overexposure:EYES- TEMPORARY IRRITATION. SKIN- TEMPORRY
IRRITATION. INHALATION- TEMPORARY IRRITATION TO MUCOUS MEMBRANES.
INGESTION- TEMPORARY IRRITATION.
Medical Cond Aggravated by Exposure:PREEXISTING DISEASES OR OTHER
CONDITIONS OF THE LUNGS, SKIN, EYES, AND OTHER MUCOUS MEMBRANES.
EXPOSURE IN CONJUNCTION WITH OTHER POTENTIAL CARCINOGENS (SUCH AS
CIGARETTE SMOKING) IS SYNERGISTIC.
======================= First Aid Measures =======================
First Aid:EYES- IMMEDIATELY FLUSH WITH LARGE AMOUNTS OF RUNNING WATER
AS NEEDED. SKIN- WASH AREA WITH SOAP AND WATER. INHALATION-
IMMEDIATELY REMOVE VICTIM FROM THE DVERSE ENVIRONMENT TO FRESH AIR
AND SEEK MED ICAL ATTENTION. INGESTION- GIVE 1-2 GLASSES OF WATER
OR MILK. NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
LEAVE DECISION TO INDUCE VOMITING FOR A DOCTOR.
===================== Fire Fighting Measures =====================
Extinguishing Media:AS APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures:AS APPROPRIATE FOR SURROUNDING FIRE.
GENERALLY, FIRE FIGHTERS SHOULD WEAR FULL TURNOUT (BUNKER) GEAR AND
FULL RESPIRTORY PROTECTION (SCBA GEAR).
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN UP USING METHODS WHICH AVOID DUST
GENERATION. IF A VACUUM IS USED, EXHUST AIR SHOULD BE FILTERED BY
A HIGH-EFFICIENCY PARTICULATE AIR (HEPA) FILTER. DO NOT USE
COMPRESSED AIR TO CLEAN UP SPILLS .
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A DRY AREA. MINIMIZE DUST
GENERATION AND AVOID INHALATION AND CONTACT WITH DUSTS.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE AN APPROPRIATE NIOSH/MSHA APPROVED
RESPIRATOR IF AIRBORNE CONTAMINANT CONCENTRATIONS EXCEED APPLICABLE
OSHA OR ACGIH LIMITS.
Ventilation:USE LOCAL AND/OR GENERAL DILUTION VENTILATION, AS NEEDED,
TO REDUCE EMPLOYEE EXPOSURES.
Other Protective Equipment:CLOTHING WHICH MINIMIZES SKIN EXPOSURE.
Work Hygienic Practices:USE GOOD PERSONAL HYGIENE WHEN HANDLING THIS
PRODUCT. WASH HANDS AFTER USE, BEFORE SMOKING, OR BEFORE USING THE
TOILET.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:2.5
Solubility in Water:INSOLUBLE
Appearance and Odor:TAN/BROWN SOLID WITH NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS AND STRONG ALKALIS MAY ATTACK PRODUCT.
==================== Disposal Considerations ====================
Waste Disposal Methods:COMPLY WITH FEDERAL, STATE, AND LOCAL
REGULATIONS REGARDING DISPOSAL.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Preparer's Name:DOD HMIS/DGSC-SSH
CAGE:JO772
CAGE:14153
CAGE:JO772
============= Composition/Information on Ingredients =============
Ingred Name:ASBESTOS, CHRYSOTILE
CAS:12001-29-5
RTECS #:CI6478500
OSHA PEL:0.2 FIBERS/CC
ACGIH TLV:2 FIBERS/CC; A1;9192
Ingred Name:ASBESTOS & STEEL COMPOSITION
RTECS #:9999999ZZ
Ingred Name:GENERIC "MSDS". SPECIFIC ASBESTOS TYPE NOT KNOWN. ONE
CITED IS ASSUMED. INFORMATION BASED ON SEGMENT "M" OF "DLSC TIR"
RTECS #:9999999ZZ
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: NO ACUTE EFFECTS ARE KNOWN;
CHRONIC: DUST FROM ABRASIVE ACTIONS(EG. CUTTING, MACHINING,
FILING, ETC.) MAYCONTAIN ASBESTOS FIBERS. CHRONIC OVEREXPOSURE
TO AIRBORNE FIBERS MAY LEAD TO ASBESTOSIS & MESOTHELIOMA.
SMOKINGCOMBINED W/FIBER INHALATION GREATLY INCREASES LUNG
CANCER RISK!
Explanation of Carcinogenicity:OVEREXPOSURE TO AIRBORNE CONCENTRATIONS
OF ASBESTOS MAY LEAD TO ASBESTOSIS AND MESOTHELIOMA.
Effects of Overexposure:INHAL: INHALATION OF AIRBORNE DUST CONTAINING
ASBESTOS FIBERS ON REPEATED EXPOSURE MAY CAUSE OR CAN LEAD TO
ASBESTOSIS/ MESOTHELIOMA; SKIN: N/K; EYE: POTENTIAL IRRITATION
FROM AIRBORNE DUST; INGEST: N/K.
Medical Cond Aggravated by Exposure:RESPIRATORY DEFICIENCIES DUE TO
REPEATED INHALATION OF AIRBORNE FIBERS.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. OBTAIN MEDICAL ADVICE; SKIN:
WASH EXPOSED AREA WITH SOAP & WATER; EYE: FLOOD W/ WATER. IF
IRRITATION OCCURS, GET MEDICAL ATTN; INGEST: CONSULT A
PHYSICIAN; OTHER: CHANGE CLOTHING AS REQUIRED TO AVOIDCARRYING
DUST PARTICLES INTO OTHER AREAS
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:MATERIAL IS NOT FLAMMABLE ; USE MEDIA APPROPRIATE
FOR SURROUNDING FIRE.
Fire Fighting Procedures:COMBUSTION PRODUCTS OF THIS MATERIAL MAY BE
TOXIC. USE A SELF-CONTAINED BREATHING APPARATUS WHEN FIGHTING FIRES
INVOLVING CHEMICAL PRODUCTS.
Unusual Fire/Explosion Hazard:NONE KNOWN
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION. VACUUM OR WET
CLEAN IF DUST IS INVOLVED. ANY VACUUM SYSTEM SHOULD BE EQUIPPED W/
AN OUTLET "HEPA" FILTER TO PREVENT REINTRODUCING ASBESTOS FIBERS TO
THE ATMOSPHERE.
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLE IN A MATTER TO MINIMIZE
FORMATION OR RETENTION OF AIRBORNE DUST. USE PROPER PERSONAL
PROTECTION FOR TASK AT HAND. CHECK W/YOUR SAFETY OFFICE!!!
Other Precautions:AS MANUFACTURED, LOCKED-IN ASBESTOS DOES NOT PRESENT
A HAZARD. ONLY WHEN THE ITEM IS SUBJECTED TO ABRASIVE ACTIONS &
DUST IS GENERATED, THEN ASBESTOS FIBERS MAY BE RELEASED & BECOME
AIRBORNE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF EXPOSURES EXCEED ESTABLISHED LIMITS, A
NIOSH/MSHA APPROVED RESPIRATOR FOR ASBESTOS SHOULD BE USED.
CONSULT YOUR SAFETY OFFICE/IH PERSONNEL FOR GUIDANCE FOR THE TASK
AT HAND.
Ventilation:LOCAL EXHAUST IS RECOMMENDED IN SITUATIONS WHERE DUST IS
GENERATED BY ABRASIVE ACTIONS, ABRASION OR OTHER MEANS.
Other Protective Equipment:AS REQUIRED FOR TASK AT HAND, AND THE
GUIDANCE SET FORTH BY YOUR SAFETY OFFICE OR IH PERSONNEL
Work Hygienic Practices:DONOT INHALE DUST CREATED BY ABRADING ACTIONS.
USE FULL PROTECTION AGAINST AIRBORNE FIBERS. AVOID AIRBORNE DUST
CREATION
Supplemental Safety and Health
GENERIC "MSDS" CREATED FOR "NSN" IDENTIFIED BY "DISC" AS CONTAINING
ASBESTOS.WHEN A MANUFACTURER'S SPECIFIC "MSDS" IS PROVIDED FOR
MATERIAL PROCURED UNDER THIS NSN, THIS GENERIC "MSDS" WILL BE
REMOVED.
================== Physical/Chemical Properties ==================
HCC:T6
Evaporation Rate & Reference:NONE
Solubility in Water:NOT SOLUBLE
Appearance and Odor:MANUFACTURED COMMODITY DESCRIBED BY LOGISTICS:
"ITEM-NAME"
Percent Volatiles by Volume:NONE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:NONE KNOWN
==================== Disposal Considerations ====================
Waste Disposal Methods:DUST SHOULD BE HANDLED AS A HAZARDOUS AIR
POLLUTANT I/A/W 40CFR61 SUBPART "M" PERTAINING TO ASBESTOS. USE
LANDFILLS APPROVED FOR ASBESTOS DISPOSAL. NOTE IF ITEM UNDER
CONSIDERATION FOR DISPOSAL IS "FRIABLE OR NON-FRIABLE".
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:RESTORE-HEAVY DUTY COOLING SYSTEM CLEANER
CAGE:4H242
CAGE:4H242
============= Composition/Information on Ingredients =============
Ingred Name:CITRIC ACID (50%)
CAS:77-92-9
RTECS #:GE7350000
Fraction by Wt: 20-40%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SODIUM HYDROXIDE (SARA III)
CAS:1310-73-2
RTECS #:WB4900000
Fraction by Wt: 5-30%
OSHA PEL:2 MG/M3
ACGIH TLV:C 2 MG/M3
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SODIUM (I) NITRATE (1:1); (SODIUM NITRATE)
CAS:7631-99-4
RTECS #:WC5600000
Fraction by Wt: 2-10%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SILICIC ACID (H*2SIO*3), DISODIUM SALT; (SODIUM
METASILICATE)
CAS:6834-92-0
RTECS #:VV9275000
Fraction by Wt: 1-5%
OSHA PEL:2 MG/M3 8HR
ACGIH TLV:2 MG/M3, C
Ingred Name:WATER
CAS:7732-18-5
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL:VAPORS/MIST MAY IRRITATE
NASAL PASSAGES. SKIN:PRLNGD/FREQUENT SKIN CONTACT MAY CAUSE
IRRITATION. EYE:PROLONGED CONTACT CAN BE DESTRUCTIVE TO TISSUE.
INGEST:HARMFUL IF SWALLOWED. ACUTE & CH RONIC OVEREXPOSURE:SAME AS
ABOVE.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE AFFECTED PERSONS TO FRESH AIR AND TREAT
SYMPTOMS. SKIN:WASH AFFECTED AREA THORO WITH SOAP AND WATER. REMOVE
CONTAMD CLOTHING AND WASH BEFORE REUSE. EYES:FLUSH WITH LARGE
AMOUNTS OF WATER FOR AT LEAST 15 MINUTES. GET MED ATTN. INGEST:IF
PERSON IS CONSCIOUS, GIVE LARGE AMOUNT OF WATER. CONTACT A
PHYSICIAN.
===================== Fire Fighting Measures =====================
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE KNOWN.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE CLOTHING. DIKE SPILL AND SOAK
UP ON AN INERT ABSORBENT MATERIAL. PLACE IN CONTAINER FOR DISPOSAL.
FLUSH AREA OF SPILL WITH WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE DRUMS CLOSED & AWAY FROM EXTREME
TEMPS. DO NOT FREEZE. FOR INDUSTRIAL USE ONLY. KEEP OUT OF REACH OF
CHILDREN.
Other Precautions:PRODUCT IS CLASSIFIED AS A HAZ WASTE DUE TO
CORROSIVITY (D002, 40 CFR 261). THIS PRODUCT IS NOT FORMULATED
W/CHEMICALS SUBJECT TO REPORTING REQUIREMENTS OF SECTION 313 OF
EMER PLANNING AND COMMUNITY R IGHT-TO-KNOW ACT OF 1986 AND 40 CFR
372.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SPECIAL. NIOSH/MSHA APPROVED RESPIRATOR
APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:USE ADEQUATE MECHANICAL VENTILATION.
Other Protective Equipment:LONG SLEEVE WORK SHIRT AND PANTS. EMERGENCY
EYEWASH & DELUGE SHOWER WHICH MEET ANSI DESIGN STANDARDS .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
PH:13.1 (10% SOLUTION). EYE PROT:FULL LENGTH FACESHIELD .
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>212F,>100C
Spec Gravity:1.29 (H*20=1)
pH:SUPDAT
Evaporation Rate & Reference:<1 (BUTYL ACETATE = 1)
Solubility in Water:APPRECIABLE
Appearance and Odor:AMBER, FREE FLOWING LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NOT KNOWN.
Hazardous Decomposition Products:NOT KNOWN.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE AND
LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:SP249
CAGE:JO764
CAGE:81831
CAGE:JO764
============= Composition/Information on Ingredients =============
Ingred Name:POLYCHLORINATED BIPHENYLS (PCBS) (SARA III)
CAS:1336-36-3
RTECS #:TQ1350000
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Effects of Overexposure:ABSORBED THRU SKIN,LUNGS,INTESTINE.CAUSES
CANCER,LIVER,KIDNEY,STOMACH,EYE,HEARING DISORDER(SUP DATA)
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/WATER IMMEDIATELY.SKIN:WASH W/SOAP
IMMEDIATELY.INHAL:REMOVE TO FRESH AIR,GIVE ART.RESPIR.AS
NEEDED.INGEST:GET MEDICAL ATTN.GIVE LARGE QTY OF SALT WATER,INDUCE
VOMITING,BUT DO NOT MAKE UNC ONSCIOUS PERSON VOMIT.
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT & DIKES TO PREVENT
RUNOFF.ISOLATE & NOTIFY PROPER AUTHORITIES.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE MUST FOLLOW RCRA REQUIREMENTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SUPPLIED AIR W/FULL FACEPIECE,HELMET OR HOOD
Ventilation:LOCAL EXHAUST
Other Protective Equipment:FULL CLOTHING TO PREVENT SKIN CONTACT
Supplemental Safety and Health
OVEREXPOS:CAN CAUSE FORMATION OF CYSTS,CAUSES STILLBIRTHS.IRRITATES
EYES,NOSE THROAT.
================== Physical/Chemical Properties ==================
HCC:Z3
Appearance and Odor:LIGHT STRAW-COLORED LIQUID,AROMATIC ODOR
================= Stability and Reactivity Data =================
STRONG OXIDIZERS
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-GENERALLY HIGH
TEMPERATURE INCINERATION.ONLY APPROVED DISPOSAL OPERATOR PERMITTED.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:LIQUID SCALE DISSOLVER
Preparer's Name:R. C. JENTE
CAGE:8F013
CAGE:8F013
============= Composition/Information on Ingredients =============
Ingred Name:HYDROCHLORIC ACID (SARA III)
CAS:7647-01-0
RTECS #:MW4025000
Fraction by Wt: 26%
OSHA PEL:5 PPM, C
ACGIH TLV:5 PPM, C
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENT.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES/SKIN:CORROSIVE TO TISSUES.
CAUSES BURNS TO EYES & SKIN. INGEST:HARMFUL IF SWALLOWED. BURNS TO
MOUTH, THROAT & STOMACH ARE LIKELY. INHAL:MISTS MAY CAUSE COUGHING
& IRRITATION TO RESPIRATORY TRACT. CHRONIC: NO AVAILABLE
INFORMATION WAS FOUND.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES/SKIN:IMMEDIATELY FLUSH EYES/SKIN W/PLENTY OF WATER FOR
AT LEAST 15 MINS WHILE REMOVING CONTAMINATED CLOTHING & SHOES. CALL
MD. WASH CLOTHING BEFORE REUSE. INGEST:IF SWALLOWED, DO NOT INDUCE
VOMIT ING. GIVE LARGE QUANTITIES OF WATER. CALL MD IMMEDIATELY.
INHAL:REMOVE TO FRESH AIR & CONTACT MD.
===================== Fire Fighting Measures =====================
Flash Point:NOT FLAMMABLE
Extinguishing Media:PRODUCT IS NOT FLAMMABLE. USE WATER SPRAY TO COOL
FIRE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE CLOTHING .
Unusual Fire/Explosion Hazard:THIS PRODUCT CAN REACT W/METALS TO
RELEASE HYDROGEN GAS. FIREMEN MAY NEED TO PROTECT AGAINST THIS.
================== Accidental Release Measures ==================
Spill Release Procedures:DIKE AREA. CONTAIN AS MUCH SPILLED MATERIAL AS
POSSIBLE. COVER W/SODIUM BICARBONATE OR SODA ASH & FLUSH W/WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT GET IN EYES, ON SKIN OR CLTHG.
AVOID BRTHG VAP/MIST. KEEP CONTR CLSD. KEEP FROM CONT W/CHLORINE
BLEACHES. READ/OBSERVE ALL LABELED PRECAUTIONS.
Other Precautions:USE ONLY IN WELL-VENTILATED AREAS THAT WILL MAINTAIN
AIR LEVELS BELOW LIMITS ESTABLISHED BY FEDERAL, STATE & LOCAL
REGULATIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:A NIOSH/MSHA APPROVED RESPIRATORY FOR ACIDS IS
RECOMMENDED.
Ventilation:LOCAL & MECHANICAL EXHAUST IS RECOMMENDED.
Other Protective Equipment:PROTECTIVE CLOTHING
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
SPEC GRAV:1.095-1.125 @ 25C (H*2O=1).
================== Physical/Chemical Properties ==================
HCC:C1
Boiling Pt:B.P. Text:>212F,>100C
Spec Gravity:SUPP DATA
pH:<1
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR ORANGE-COLORED LIQUID WITH SHARP ODOR
Percent Volatiles by Volume:100 WT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
BASES, STRONG OXIDIZERS & METALS.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:METAL CONTACT MAY GENERATE HYDROGEN,
WHICH CAN BE EXPLOSIVE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:L774, ETHYL FORMATE
CAGE:DO803
CAGE:DO803
CAGE:70829
============= Composition/Information on Ingredients =============
Ingred Name:FORMIC ACID, ETHYL ESTER; (ETHYL FORMATE)
CAS:109-94-4
RTECS #:LQ8400000
Fraction by Wt: 90-100%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(ORAL,RAT)1850 MG/KG.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NONE SPECIFIED BY MANUFACTURER.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:VAPORS MAY BE IRRITATING TO SKIN, EYES, NOSE
AND THROAT. INHALATION OF VAPORS MAY CAUSE NARCOSIS.
Medical Cond Aggravated by Exposure:NONE IDENTIFIED.
======================= First Aid Measures =======================
First Aid:CALL MD. INGEST:IF SWALLOWED, DO NOT INDUCE VOMITING; IF
CONSCIOUS, GIVE WATER, MILK OR MILK OF MAGNESIA. INHAL:REMOVE TO
FRESH AIR. IF NOT BREATHING, GIVE ARTIFICIAL RESPIRATION. IF
BREATHING DIFFICU LT, GIVE OXYGEN. EYE:IMMEDIATELY FLUSH W/PLENTY
OF WATER FOR AT LEAST 15 MINUTES. SKIN:FLUSH W/WATER.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:-4F,-20C
Lower Limits:2.8%
Upper Limits:16%
Extinguishing Media:USE ALCOHOL FOAM, DRY CHEMICAL OR CARBON DIOXIDE.
(WATER MAY BE INEFFECTIVE.)
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .MOVE CNTNRS FROM FIRE AREA IF CAN BE DONE
W/OUT RISK. USE WATER TO KEEP FIRE-EXPSD CNTNRS COOL.
Unusual Fire/Explosion Hazard:VAPORS MAY FLOW ALONG SURFACES TO DISTANT
IGNITION SOURCES AND FLASH BACK. CLOSED CNTNRS EXPOSED TO HEAT MAY
EXPLODE. CONTACT W/STRONG OXIDIZERS MAY CAUSE FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR SUITABLE PROT CLTHG. SHUT OFF IGNIT
SOURCES; NO FLARES, SMOKING/FLAMES IN AREA. STOP LEAK IF CAN DO SO
W/OUT RISK. USE WATER SPRAY TO REDUCE VAPS. TAKE UP W/SAND OR OTHER
NON-COMBUST ABSORB MATL & PLACE INTO CNTNR FOR LATER DISPOSAL.
(SUPP DATA)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CNTNR TIGHTLY CLOSED. STORE IN
COOL, DRY, WELL-VENT, FLAMMABLE LIQUID STORAGE AREA. KEEP PROD OUT
OF LIGHT. KEEP AWAY FROM HEAT, SPARKS & FLAME.
Other Precautions:BOND AND GROUND CONTAINERS WHEN TRANSFERRING LIQUID.
AVOID BREATHING VAPOR. USE W/ADEQUATE VENTILATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESP PROT REQUIRED IF AIRBORNE CONCENTRATION
EXCEEDS TLV. AT CONCENTRATIONS UP TO 100 PPM, A NIOSH/MSHA APPROVED
CHEMICAL CARTRIDGE RESPIRATOR W/ORGANIC VAPOR CARTRIDGE IS
RECOMMENDED. ABOVE THIS LEVE L, A NIOSH/MSHA APPRVD SCBA
RECOMMENDED.
Ventilation:USE ADEQUATE GENERAL OR LOCAL EXHAUST VENTILATION TO KEEP
VAPOR AND MIST LEVELS AS LOW AS POSSIBLE.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
SPILL PROC:FLUSH AREA W/WATER. J.T. BAKER SOLUSORB(R) SOLVENT ADSORBENT
IS RECOMMENDED FOR SPILLS OF THIS PRODUCT.
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:129F,54C
Melt/Freeze Pt:M.P/F.P Text:-114F,-81C
Vapor Pres:194
Vapor Density:2.55
Spec Gravity:0.92 (H2O=1)
Evaporation Rate & Reference:1.8 (BUTYL ACETATE = 1)
Solubility in Water:MODERATE (1-10%)
Appearance and Odor:CLEAR, COLORLESS LIQUID W/PLEASANT AROMATIC ODOR.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG BASES, STRONG ACIDS, NITRATES.
Stability Condition to Avoid:HEAT, FLAME, SOURCES OF IGNITION, LIGHT.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF I/A/W ALL APPLICABLE FEDERAL, STATE
AND LOCAL ENVIRONMENTAL REGULATIONS. EPA HAZARDOUS WASTE
NUMBER:D001 (IGNITABLE WASTE).
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:2600 BLANKET
CAGE:19740
CAGE:19740
============= Composition/Information on Ingredients =============
Ingred Name:ALUMINUM SILICATE (AS NUISANCE DUST OR PARTICULATES NOT
OTHERWISE REGULATED)
CAS:1302-76-7
RTECS #:BD1450000
Fraction by Wt: 100%
OSHA PEL:15 MG/M3 TOTAL DUST
ACGIH TLV:10 MG/M3 TDUST;8990
===================== Hazards Identification =====================
Effects of Overexposure:INHALATION, INGESTION AND SKIN IRRITATION
======================= First Aid Measures =======================
First Aid:TERMINATE EXPOSURE.
======================Handling and Storage ======================
Handling and Storage Precautions:REMOVAL OF THIS PRODUCT AFTER USE MAY
RESULT IN THE GENERATION OF DUST.
Other Precautions:REPEATED INHALATION OF RESPIRABLE FREE CRYSTALLINE
SILICA DUST MAY CAUSE DELAYED LUNG INJURY (SILICOSIS).
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FULL FACEPIECE RESPIRATOR W/APPROPRIATE FILTER
PAD OR CARTRIDGE(S)
Ventilation:LOCAL EXHAUST AND MECHANICAL
Other Protective Equipment:LONG SLEEVE, LOOSE FITTING CLOTHING AND
BARRIER CREAM.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Spec Gravity:2.56
Solubility in Water:INSOLUBLE
Appearance and Odor:WOOL-LIKE FIBROUS MATERIAL. NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:ROUTINE HOUSEKEEPING.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:BITUTHENE WATERPROOFING STRIPS 3000
CAGE:IO516
CAGE:17486
CAGE:IO516
============= Composition/Information on Ingredients =============
Ingred Name:ASPHALT
CAS:8052-42-4
RTECS #:CI9900000
Fraction by Wt: 30-55%
Ingred Name:MINERAL OIL, PETROLEUM EXTRACTS, HEAVY PARAFFINIC
DISTILLATE SOLVENT; (UNPROCESSED NAPHTHENIC OIL)
CAS:64742-04-7
RTECS #:PY8042500
Fraction by Wt: 15-35%
Ingred Name:CALCIUM CARBONATE
CAS:1317-65-3
RTECS #:EV9580000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:STYRENE POLYMER WITH 1,3-BUTADIENE; (STYRENE BUTADIENE
POLYMER)
CAS:9003-55-8
RTECS #:WL6478000
Ingred Name:POLYOLEFIN FILM OR MESH
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(ORAL,RAT)5 GM/KG(ESTIMATED)
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL: THERE ARE NO KNOWN HLTH
EFTS. DUE TO PHYSICAL NATURE OF PROD, INHAL IS UNLIKELY. SKIN &
EYE: PRLNGD/RPTD CONT TO OIL IN PROD MAY RSLT IN SLIGHT SKIN IRRIT.
ANIMAL TESTS INDICATE THAT PRL NGD & RPTD SKIN CONT TO ASPHALT IN
PRODMAY PRODUCE LOCAL SKIN TUMORS. HOWEVER, WE ARE NOT AWARE OF
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:UNPROCESSED NAPHTHENIC OIL: GROUP 1(IARC
SUPP7, P252, '87).
Effects of Overexposure:HLTH HAZ: ANY EVIDENCE THAT SKIN CONT WILL
CAUSE CANCER IN HUMANS. EYE CONT W/OIL RESIDUE MAY RSLT IN IRRIT.
INGEST: THERE ARE NO KNOWN HLTH EFTS. DUE TO PHYSICAL NATURE OF
PROD, INGEST IS UNLIKELY. P ROD CNTNS 15-35 OF AN UNPROCESSED
NAPHTHENIC OIL WHICH HAS BEEN SHOWN TO CAUSE SKIN CANCER IN LAB
ANIMALS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:SKIN: THORO CLEAN FINGERNAILS & WASH HANDS W/SOAP AND WATER,
WATERLESS HAND CREAMS/ABRASIVE SOAP. EYE: FLUSH WITH PLENTY OF
WATER FOR AT LEAST 15 MINUTES. CONSULT A PHYSICIAN IF EYE/SKIN
IRRITATION DE VELOPS OR IF SWALLOWED. INHAL: REMOVE TO FRESH AIR.
SUPPORT BRTHG (GIVE O*2/ARTF RESP) . INGEST: CALL MD IMMED .
===================== Fire Fighting Measures =====================
Flash Point Method:OC
Flash Point:>410F,>210C
Extinguishing Media:WATER FOG, ALCOHOL FOAM, DRY CHEMICAL, CARBON
DIOXIDE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:REMOVAL OF THE RELEASE PAPER MAY GENERATE
A STATIC ELECTRICAL DISCHARGE (SPARK). DO NOT REMOVE RELEASE PAPER
WHERE SPARK MAY IGNITE FLAMMABLE VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:WASTE OF THIS PRODUCT IS NOT DEFINED AS
HAZARDOUS ACCORDING TO U.S EPA (40CFR261.3).
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID PRLNGD/RPTD CONT W/SKIN. AVOID
RUBBING EYES WHILE HANDLING. DO NOT REMOVE RELEASE PAPER WHERE
SPARK MAY IGNITE FLAMM VAPS.
Other Precautions:FOR PROFESSIONAL USE ONLY. KEEP OUT OF REACH OF
CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE OF RESPIRATORY PROTECTION IS NOT REQUIRED
DURING NORMAL USE. USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:NOT REQUIRED FOR NORMAL USE.
Other Protective Equipment:BARRIER CREAMS IS RECOMMENDED.
Work Hygienic Practices:AVOID RUBBING EYES WHILE HNDLG. DUE TO PHYSICAL
NATURE OF PROD, INGEST IS UNLIKELY. INCIDENTAL INGEST OF (SUPP
DATA)
Supplemental Safety and Health
HYGIENE PRACT: RUBBERIZED ASPHALT RESIDUE IS NOT EXPECTED TO CAUSE
ADVERSE HEALTH EFFECTS BUT SHOULD BE AVOIDED BY USING GOOD PERSONAL
HYGIENE PRACTICES.
================== Physical/Chemical Properties ==================
Spec Gravity:0.9(H*2O=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:RUBBERIZED ASPHALT ADHESIVE SHEET. PETROLUEM ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON MONOXIDE, SULFUR OXIDES,
ASPHYXIANTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF ALL WASTE IN ACCORDANCE WITH
APPLICABLE FEDERAL, STATE, AND LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:PROTEK-SORB
Preparer's Name:J.H. CONVEY
CAGE:16210
CAGE:16210
============= Composition/Information on Ingredients =============
Ingred Name:SILICA GEL
CAS:63231-67-4
RTECS #:VV7322000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:80 MG/M3 / % SIO2
ACGIH TLV:10 MG/M3
Ingred Name:CARBON BLACK OR ACTIVATED CARBON
CAS:7440-44-0
RTECS #:FF5250100
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:2 MG/M3 RDUST; 9394
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: THE DRYING ACTION OF THIS
MATERIAL CAN CAUSE IRRITATION OF THE MUCOUS MEMBRANES OF THE NOSE
AND THROAT AND IRRITATION OF SKIN. CHRONIC: SAME AS ACUTE.
Explanation of Carcinogenicity:NO INGREDIENT OF A CONCENTRATION OF 0.1%
OR GREATER IS LISTED AS A CARCINOGEN OR SUSPECTED CARCINOGEN.
Effects of Overexposure:INHALED- SORE THROAT, SNEEZING, WHEEZING,
COUGHING. SKIN: REDNESS, ITCHING, DISCOMFORT.
Medical Cond Aggravated by Exposure:NONE KNOWN BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES-IMMEDIATELY FLUSH WITH LOTS OF WATER, LIFT LIDS
OCCASIONALLY LIFTING LIDS. SEEK MEDICAL ATTENTION IF IRRITATION
OCCURS & PERSISTS. SKIN-WASH WITH SOAP & WATER. INHALED-REMOVE TO
FRESH AIR. INGEST ED-MATERIAL WILL PASS THROUGH THE BODY NORMALLY.
===================== Fire Fighting Measures =====================
Flash Point:NON FLAMMABLE
Extinguishing Media:NONE SPECIFIED BY MANUFACTURER. DLA-HMIS: MEDIA
APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures:NONE SPECIFIED BY MANUFACTURER. DLA-HMIS:
FIREFIGHTERS SHOULD WEAR FULL PROTECTIVE CLOTHING INCLUDING
POSITIVE-PRESSURE SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP OR VACUUM UP OR FLUSH TO SEWER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP SEALED TIGHTLY TO PROTECT
QUALITY.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF ENGINEERING CONTROLS FAIL OR NON-ROUTINE USE
OR EMERGENCY OCCURS; USE NIOSH/MSHA APPROVED RESPIRATOR WITH DUST
CARTRIDGE. USE IAW 29 CFR 1910.134 AND MANUFACTURER'S
RECOMMENDATIONS.
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH HANDS AFTER USE AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:2.1
Solubility in Water:INSOLUBLE
Appearance and Odor:BAGS/PACKETS & CLOSURES CONTAINING WHITE
GRANULAR/BEADED SILICA GEL/BLACK CARBO
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
HYDROGEN FLUORIDE.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER. DLA-HMIS:
AVOID CONTACT WITH HYDROGEN FLUORIDE.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN AN APPROVED LANDFILL ACCORDING TO
LOCAL, STATE AND FEDERAL REGULATIONS. COVER PROMPTLY TO AVOID
BLOWING OF DUST.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:KRYLON ENGINE COLORS, 2106 FORD RED
CAGE:07982
CAGE:86142
CAGE:07982
============= Composition/Information on Ingredients =============
Ingred Name:ACETONE (SARA 313) (CERCLA)
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 10-30%
OSHA PEL:1000 PPM
ACGIH TLV:750 PPM; 1000 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 10-30%
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT
Ingred Name:ACETIC ACID, 2-METHOXY-1-METHYLETHYL ESTER; (2-PROPANOL,
1-METHOXY-, ACETATE)
CAS:108-65-6
RTECS #:AI8295000
Fraction by Wt: 5-10%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:HEXANE (CERCLA)
CAS:110-54-3
RTECS #:MN9275000
Fraction by Wt: 10-30%
OSHA PEL:500 PPM
ACGIH TLV:50 PPM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:LIGROINE; (VM&P NAPHTHA)
CAS:8032-32-4
RTECS #:OI6180000
Fraction by Wt: 10-30%
OSHA PEL:300 PPM
ACGIH TLV:300 PPM
Ingred Name:FIRST AID PROC: IRRIGATION TO INSURE WATER CONTACT W/ENTIRE
SURFACE OF EYES & LIDS. CALL MD.
RTECS #:9999999ZZ
Ingred Name:VENT: SHOULD BE PROVIDED TO KEEP AIR CONTAMINANT CONC
LEVELS BELOW ACCEPTABLE CRITERIA. FOLLOWING EXPOS CONTROL (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7: TECHNIQUES MAY BE USED TO EFTIVELY MINIMIZE EMPLOYEE
EXPOS: LOC EXHST VENT. ENCLSD SYS DESIGN. PROCESS (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8: ISOLATION & REMOTE CONTROL IN COMBINATION W/APPROP
USE OF PERSONAL PROT EQUIP & PRUDENT WORK PRACTICES. (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9: THESE TECHNIQUES MAY NOT NECESSARILY ADDRESS ALL
ISSUES PERTAINING TO OPERATIONS. THEREFORE, MFR RECOMS (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10: CONSULTATION W/EXPERTS OF CHOICE TO DETERMINE
WHETHER OR NOT PROGRAMS ARE ADEQUATE.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INGEST: NOT EXPECTED TO BE HARMFUL
UNDER NORMAL CONDITIONS OF USE. IF ACCIDENTLY SWALLOWED, BURNS OR
IRRIT TO MUC MEMBS, ESOPHAGUS OR GI TRACT CAN RSLT. INHAL: MAY BE
HARMFUL IF INHALED. LIQ/VAP MAY C AUSE IRRIT OF NOSE, THROAT &
LUNGS. CANCAUSE CNS DEPRESS. SIGNS & SYMPS MAY INCL HDCH, DIZZ,
NAUS, (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: VOMIT, UNCON & EVEN ASPHYXIATION.
SKIN/EYES: CAUSES IRRIT. PROPANE IS SIMPLE ASPHYXIANT. SIGNS &
SYMPS OF OVEREXP INCL CYANOSIS, RESP DISTRESS, HDCH, DIZZ, DROW,
UNCON & ASPHYXIATION. CHRONI C EXPOSURES TO HEXANE HAVE CAUSED
PERIPHERAL NEUROPATHY.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST: DILUTE BY DRINKING LG QTYS OF WATER. IMMED CNTCT POIS
CTL CTR OR HOSPITAL EMER ROOM FOR ANY OTHER ADDNL TREATMENT
DIRECTIONS. INHAL: REMOVE TO FRESH AIR. IF NOT BRTHG GIVE ARTF
RESP, PREFERABL Y MOUTH-TO-MOUTH. SKIN: FLUSH W/PLENTY OF WATER.
REMOVE CONTAMD CLTHG. CALL MD IF IRRIT PERSISTS. EYES: IMMED FLUSH
W/PLENTY OF WAATER FOR AT LEAST 15 MIN. EYELIDS SHOULD BE HELD
APART DURING (ING 6)
===================== Fire Fighting Measures =====================
Flash Point:EXTREMELY FLAMM
Extinguishing Media:USE DRY CHEMICAL, FOAM OR CARBON DIOXIDE. WATER MAY
BE INEFFECTIVE, BUT SHOULD BE USED TO KEEP FIRE-EXPOSED CNTNRS
COOL.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:EXTREMELY FLAMM. DO NOT INCIN(BURN)
CNTNR. AVOID HEAT. KEEP CNTNR <120F. HIGH TEMP MAY CAUSE BURSTING.
DO NOT PLACE CNTNR ON RADIATOR, STOVE, IN DIRECT (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES. SOAK UP WITH
ABSORBENT MATERIAL AND REMOVE TO A CHEMICAL DISPOSAL AREA. PREVENT
ENTRY INTO NATURAL BODIES OF WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE AT TEMPERATURES ABOVE
120F.
Other Precautions:AVOID BREATHING VAPOR OR MIST. USE WITH ADEQUATE
VENTILATION. AVOID CONTACT WITH SKIN. AVOID CONTACT WITH EYES. WASH
THOROUGHLY AFTER HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHERE AIR CONTAMINANTS CAN EXCEED ACCEPTABLE
CRITERIA, USE NIOSH/MSHA APPRVD RESP PROT EQUIP. RESPS SHOULD BE
SELECTED BASED ON FORM & CONC OF CONTAMINANTS IN AIR I/A/W OSHA 29
CFR 1910.134 OR OTHER A PPLIC STANDARDS OR GUIDELINES.
Ventilation:IF AIRBORNE CONTAMINANTS ARE GENERATED WHEN MATL IS
HEATED/HANDLED, SUFFICIENT VENT IN VOL & AIR FLOW PATTERNS (ING 7)
Other Protective Equipment:EYEWASH FOUNTAIN & DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA .
Work Hygienic Practices:HANDLE I/A/W GOOD INDUS HYGIENE & SFTY PRACTS;
INCLUDES AVOIDING UNNEC EXPOS & REMOVAL OF MATL FROM EYES, SKIN &
CLTHG.
Supplemental Safety and Health
% VOLAT: 78-89 (WT). EXPLO HAZ: SUN/NEAR OTHER HEAT SOURCES. DO NOT
PUNCTURE CNTNR. CONTENTS UNDER PRESS WILL DISCHARGE. AVOID OPEN
FLAMES, SPKS, PILOT LIGHTS. DO NOT SMOKE. VAP MAY IGNIT EXPLO.
SPRAY MIST/VAP EVAP FROM DEPOSITED FILM IS HVR/AIR & MAY SETTLE IN
LOW PLACES/TRAVEL OUTWARD TO SOURCE OF IGNIT & FLASH BACK.
================== Physical/Chemical Properties ==================
Vapor Pres:60 PSIG
Vapor Density:HVR/AIR
Spec Gravity:LTR/H*2O
Evaporation Rate & Reference:FASTER/BUTYL ACETATE
Solubility in Water:SLIGHT
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:SUPDAT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG BASES, OXIDIZERS.
Stability Condition to Avoid:NORMALLY STABLE AS DEFINED IN NFPA
704-12(4-3.1).
Hazardous Decomposition Products:OXIDES OF CARBON.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF ACCORDING TO LOCAL, STATE/PROVINCIAL
& FEDERAL REQUIREMENTS. EMPTY CONTAINER MAY CONTAIN EXPLOSIVE
VAPORS. DO NOT CUT, PUNCTURE OR WELD ON OR NEARBY. INCINERATION
WILL CAUSE CONTAINER TO BU RST VIOLENTLY.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:LEAD-ACID BATTERY
Preparer's Name:NOT PROVIDED
CAGE:20038
Contract Num:SP0430-01-M-FQ40
CAGE:0FTM0
CAGE:20038
============= Composition/Information on Ingredients =============
Ingred Name:LEAD
CAS:7439-92-1
RTECS #:OF7525000
Minumum % Wt:54.
Maxumum % Wt:62.
Other REC Limits:NIOSH 100 UG;MFR
OSHA PEL:50 UG/M3
ACGIH TLV:150 UG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:ANTIMONY
CAS:7440-36-0
RTECS #:CC4025000
= Wt:.4
Other REC Limits:-
OSHA PEL:500 UG/M3
ACGIH TLV:500 UG/M3
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ARSENIC
CAS:7440-38-2
RTECS #:CG0525000
= Wt:.01
Other REC Limits:--
OSHA PEL:10 UG/M3
ACGIH TLV:200 UG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:CALCIUM
CAS:7440-70-2
RTECS #:EV8040000
= Wt:.02
Other REC Limits:--
OSHA PEL:--
ACGIH TLV:--
Ingred Name:TIN
CAS:7440-31-5
RTECS #:XP7320000
= Wt:.16
Other REC Limits:--
OSHA PEL:2000 UG/M3
ACGIH TLV:2000 UG/M3
Ingred Name:ELECTROLYTE (SULFURIC ACID/WATER/SOLUTION)
CAS:7664-93-9
RTECS #:WS5600000
Minumum % Wt:26.
Maxumum % Wt:40.
Other REC Limits:NIOSH, 1000 UG/M3
OSHA PEL:1000 UG/M3
ACGIH TLV:1000 UG/M3
ACGIH STEL:3 MG/M3
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:POLYPROPYLENE
CAS:9003-07-0
RTECS #:UD1842000
Minumum % Wt:5.
Maxumum % Wt:12.
Ingred Name:HARD RUBBER
Ingred Name:PLATE SEPERATOR MATERIAL: POLYETHYLENE
CAS:9002-88-4
RTECS #:KX3270000
Minumum % Wt:1.
Maxumum % Wt:2.
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: ELECTROLYTE: SEVERE SKIN
IRRITATION, DAMAGE TO CORNEA MAY CAUSE BLINDNESS, UPPER RESPIRATORY
IRRITATION. LEAD COMPOUNDS: SYMPTOMS OF TOXICITY INCLUDE HEADACHE,
FATIGUE, ABDOMINAL PAIN, LOSS OF APPETITE, MUSCULAR ACHES AND
WEAKNESS, SLEEP DISTURBANCES AND IRRITABILITY. CHRONIC:
ELECTROLYTE: POSSIBLE EROSION OF TOOTH ENAMEL; INFLAMMATION OF
NOSE, THROAT AND BRONCHIAL TUBES. LEAD COMPOUNDS: AN EMIA;
NEUROPATHY, PARTICULARLY OF THE MOTOR NERVES, WITH WRIST DROP;
KIDNEY DAMAGE; REPRODUCTIVE CHANGES IN BOTH MALES AND FEMALES.
Explanation of Carcinogenicity:LEAD COMPOUNDS: LISTED AS 2B CARCINOGEN,
LIKELY IN ANIMALS AT EXTREME DOSES. PROOF OF CARCINOGENICITY IN
HUMANS IS LACKING AT PRESENT. ARSENIC: LISTED BY NATIONAL
TOXICOLOGY PROGRAM (NTP), INTERNATI ONAL AGENCY FOR RESEARCH ON
CANCER (IARC), OSHA AND NIOSH AS A CARCINOGEN ONLY AFTER PROLONGED
EXPOSURE AT HIGH LEVELS.
Effects of Overexposure:INHALATION: ELECTROLYTE: BREATHING OF SULFURIC
ACID VAPORS OR MISTS; SEVERE RESPIRATORY IRRITATION. LEAD
COMPOUNDS: INHALATION OF LEAD DUST OR FUMES CAUSE IRRITATION OF
UPPER RESPIRATORY TRACT, LUNGS. INGESTION: ELECTROLYTE: CAUSE
SEVERE IRRITATION OF MOUTH, THROAT, ESOPHAGUS AND STOMACH. LEAD
COMPOUNDS: ACUTE INGESTION CAUSE ABDOMINAL PAIN, NAUSEA, VOMITING,
DIARRHEA AND SEVERE CRAMPING. LEAD RAP IDLY TO SYSTEMIC TOXICITY.
SKIN: ELECTROLYTE: SEVERE IRRITATION, BURNS AND ULCERATION. LEAD
COMPOUNDS: NOT ABSORBED THROUGH SKIN. EYE: ELECTROLYTE: SEVERE
IRRITATION, BURNS, CORNEA DAMAGE, BLINDNESS. LEAD COMPOUNDS: CAUSE
EYE IRRITATION.
Medical Cond Aggravated by Exposure:SULFURIC ACID MIST: LUNG DAMAGE AND
AGGRAVATE PULMONARY CONDITIONS. ELECTROLYTE WITH SKIN; AGGRAVATE
SKIN DISEASES; ECZEMA AND CONTACT DERMATITIS. CONTACT EYES: DAMAGE
CORNEA OR BLINDNESS.
======================= First Aid Measures =======================
First Aid:INHALATION: ELECTROLYTE (WATER AND SULFURIC ACID SOLUTION):
REMOVE TO FRESH AIR IMMEDIATELY. IF BREATHING IS DIFFICULT, GIVE
OXYGEN. LEAD: REMOVE FROM EXPOSURE, GARGLE, WASH NOSE AND LIPS;
CONSULT PHY SICIAN. INGESTION: ELECTROLYTE: GIVE LARGE QUANTITIES
OF WATER; DO NOT INDUCE VOMITING; CONSULT PHYSICIAN. LEAD: CONSULT
PHYSICIAN IMMEDIATELY. SKIN: ELECTROLYTE (WATER AND SULFURIC ACID
SOLUTION): FL USH WITH LARGE AMOUNT OF WATER FOR AT LEAST 15
MINUTES; REMOVE CONTAMINATED CLOT HING. LEAD: WASH IMMEDIATELY WITH
SOAP AND WATER. EYES: FLUSH IMMEDIATELY WITH LARGE AMOUNT OF WATER
FOR AT LEAST 15 MI NUTES; CONSULT PHYSICIAN IMMEDIATELY.
===================== Fire Fighting Measures =====================
Lower Limits:4.1 HYDROGEN
Upper Limits:74.2 (H2)
Extinguishing Media:CO2, FOAM; DRY CHEMICAL.
Fire Fighting Procedures:USE POSITIVE-PRESSURE, SELF-CONTAINED
BREATHING APPARATUS. BEWARE OF ACID SPLATTER IF WATER IS USED. WEAR
BATTERIES ON CHARGE, SHUT OFF POW ER TO CHARGING EQUIPMENT. STRINGS
OF CO NNECTED BATTERES POSE RISK OF ELECTRIC SHOCK EVEN WHEN
CHARGER IS SHUT DOWN.
Unusual Fire/Explosion Hazard:IN OPERATION, BATTERIES GENERATE AND
RELEASE FLAMMABLE HYDROGEN GAS. ALWAYS ASSUME TO CONTAIN THIS GAS.
IF IGNITED BY BURNING CIGARETE, NAKED FLAME OR SPARK, MAY CAUSE
BATTERY EXPLOSION WITH DISPERSIO N OF CASING FRAGMENTS AND
CORROSIVE LIQU ID ELECTROLYTE FOLLOW MANUFACTURER'S INSTRUCTIONS
FOR INSTALLATION AND SERVICE.
================== Accidental Release Measures ==================
Spill Release Procedures:STOP FLOW OF MATERIAL, CONTAIN/ABSORB SMALL
SPILLS WITH DRY SAND, EARTH, VERMICULITE. DO NOT USE COMBUSTIBLE
MATERIALS. CAREFULLY NEUTRALIZE ELECTROLYTE WITH SODA ASH, SODIUM
BICARBONATE, LIME, ET C. WEAR ACID-RESISTANT CLOTHING, BOOTS,
GLOV ES, AND FACE SHIELD. DO NOT ALLOW DISCHARGE OF UNNEUTRALIZED
ACID TO SEWER. NEUTRALIZED ACID MUST BE MANAGED IN ACCORDANCE
WITH APPROVED REQUIREMENTS.
Neutralizing Agent:SODA ASH, LIME OR SODIUM BICARBONATE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE BATTERIES UNDER ROOF IN COOL,
DRY, WELL-VENTILATED AREAS WHICH ARE SEPARATED FROM INCOMPATIBLE
MATERIALS AND FROM ACTIVITIES WHICH MAY CREATE FLAMES, SPARKS OR
HEAT. STORE ON SMOOTH, IMPERVIOUS SURFACES WHICH ARE PROVIDED WITH
MEASURE S FOR LIQUID CONTAINMENT IN THE EVENT OF ELECTROLYTE SPILLS
Other Precautions:KEEP AWAY FROM METALLIC OBJECTS WHICH COULD BRIDGE
THETERMINALS. HANDLE CAREFULLY AND AVOID TIPPING WHICH MAY ALLOW
ELECTROLYTELEAKAGE. SINGLE BATTERY POSE NO RISK OF ELECTRIC SHOCK
BUT THERE MAY BEINCREASING RISK OF ELECTRIC SHOCK FROM STRINGS
OF CONNECTED BATTERIESEXCEEDING THREE 12-VOLT UNI TS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED UNDER NORMAL CONDITIONS. WHEN
CONCENTRATIONS OF SULFURIC ACID MIST ARE KNOWN TO EXCEED PEL, USE
NIOSH OR MSHA APPROVED RESPIRATORY PROTECTION.
Ventilation:STORE AND HANDLE IN WELL-VENTILATED AREA. IF MECHANICAL
VENTILATION IS USED, COMPONENTS MUST BE ACID-RESISTANT.
Other Protective Equipment:IN AREAS WHERE SULFURIC ACID IS HANDLED IN
CONCENTRATIONS GREATER THAN 1%, EMERGENCY EYEWASH STATIONS AND
SHOWERS SHOULD BE PROVIDED, WITH UNLIMITED WATER SUPPLY.
Work Hygienic Practices:HANDLE BATTERIES CAUTIOUSLY TO AVOID SPILLS.
MAKE CERTAIN VENT CAPS ARE ON SECURELY. AVOID CONTACT WITH
INTERNAL COMPONENTS. WEAR PROTECTIVE CLOTHING WHEN FILLING OR
HANDLING BATTERIES.
Supplemental Safety and Health
LEAD AND ITS COMPOUNDS CAN AGGRAVATE SOME FORMS OF KIDNEY, LIVER AND
NEUROLOGIC DISEASES.
================== Physical/Chemical Properties ==================
HCC:C1
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:203F-240F
Decomp Temp:Decomp Text:NOT PROVIDED
Vapor Pres:17 TO 11 @ 77F
Vapor Density:>1
Spec Gravity:1.230-1.350
Evaporation Rate & Reference:<1 (BUTYL ACETATE=1)
Solubility in Water:100 %
Appearance and Odor:A CLEAR LIQUID WITH A SHARP PENETRATING, PUNGENT
ODOR. A BATTERY IS AN ARTICLE.
Percent Volatiles by Volume:NA
Corrosion Rate:NOT PROVIDED
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ELECTROLYTE: COMBUSTIBLES, ORGANIC MATERIALS, STRONG REDUCING AGENTS,
METALS, SULFUR TRIOXIDE GAS, STRONG OXIDIZERS, WATER. LEAD
COMPOUNDS: STRONG ACIDS, BASES, HALIDES, OXIDIZERS, NASCENT
HYDROGEN, REDUCING AGENTS
Stability Condition to Avoid:PROLONGED OVERCHARGE AT HIGH CURRENT;
SOURCES OF IGNITION.
Hazardous Decomposition Products:ELECTROLYTE: SULFUR TRIOXIDE, CARBON
MONOXIDE, ACID MIST, SULFUR DIOXIDE, HYDROGEN. LEAD COMPOUNDS:
TOXIC METAL FUMES, VAPOR OR DUST. CONTACT WITH ACID/BASE OR MAY
GENERATE HIGHLY TOXIC ARSINE GAS
=================== Toxicological Information===================
Toxicological Information:ACID: HARMFUL BY ALL ROUTES OF ENTRY. LEAD
COMPOUNDS: EXPOSURE CAN OCCUR WHEN PRODUCT IS HEATED ABOVE MELTING
POINT, OXIDIZED OR DAMAGED TO CREATE DUST, VAPOR OR FUME. SULFURIC
ACID: THE INTERNATIONAL AGENCY FOR RESEARCH ON CANCER (IARC) HAS
CLASSIFIED "STRONG INORGANIC ACID MIST CONTAINING SULFURIC ACID" AS
A CATEGORY I CARCINOGEN, A SUBSTANCE THAT IS CARCINOGENIC TO
HUMANS. THIS CLASSIFICATION D OES NOT APPLY TO SULFURIC ACID
SOLUTIONS CONTAINED WITHIN A BATTERY. INORGANIC ACID MIST IS NOT
GENERATED UNDER NORMAL USE OF THIS PRODUCT. MISUSE OF THE
PRODUCT, SUCH AS OVERCHARGING, MAY RESULT IN THE GENERATION OF
SULFURIC ACID MIST.
==================== Disposal Considerations ====================
Waste Disposal Methods:SPENT BATTERIES: SEND TO SECONDARY LEAD SMELTER
FOR RECYCLING. ELECTROLYTE: PLACENEUTRALIZED SLURRY INTO SEALED
CONTAINERS AND DISPOSE OF AS HAZARDOUS WASTE, AS APPLICABLE.
LARGE WATER-DILUTED SP ILLS, AFTER NEUTRALIZATION AND TESTING, SHOU
LD BE MANAGED IN ACCORDANCE WITH LOCAL. STATE, AND FE DERAL
REQUIREMENTS.
=================== MSDS Transport Information ===================
Transport Information:U.S. DOT: WET (FILLED WITH ELECTROLYTE) BATTERIES
ARE REGULATED BY U.S. DOT AS HAZARDOUS MATERIAL. PROPER SHIPPING
NAME: BATTERIES, WET, FILLED WITH ACID. HAZARD CLASS/DIVISION: 8
ID NUMBER: UN279 4 PACKING GROUP: III LABEL REQU IRED: CORROSIVE.
FOR NON-SPILLABLE: BATTERIES, WET, NON-SPILLABLE, 8, UN2800, III.
LABEL: CORROSIVE.
===================== Regulatory Information =====================
SARA Title III Information:CERCLA (SUPERFUND) AND EPCRA: (A) REPORTABLE
QUANTITY (RQ) FOR SPILLED 100% SULFURIC ACID UNDER CERCLA
(SUPERFUND) AND EPCRA (EMERGENCY PLANNING AND COMMUNITY
RIGHT-TO-KNOW ACT) IS 1000 LBS. (B) SULFU RIC ACID IS A LISTED
"EXTREMELY HAZARDOUS SUBSTANCE" UNDER EPCRA, WITH A THRESHOLD
PLANNING QUANTITY (TPQ) OF 1000 LBS. (C) EPCRA SECTION 302
NOTIFICATION IS REQUIRED IF 1000 LBS OR MORE OF SULFURIC A CID IS
PRESENT AT ONE SITE. (D) EPCRA SECTION 312 TIER TWO REPORTING IS
REQUIRED IF ACID IS >=500 LBS, LEAD >=10000 LBS. (E) SUPPLIER
NOTIFICATION: CONTAINS TOXIC CHEMICALS REPORTABLE UNDER EPCRA SECT
ION 313:PB, H2SO4,SB, AS.
Federal Regulatory Information:RCRA: SPENT LEAD-ACID BATTERIES ARE NOT
REGULATEDAS HAZARDOUS WASTE WHEN RECYCLED. SPILLED SULFURIC
ACID IS A CHARACTERISTIC HAZARDOUS WASTE; EPA HAZARDOUS WASTE
NUMBER D002 (CORROSIVITY). TSCA :INGREDIENTS IN EXIDE'S
BATTERIES ARE LISTED IN THE TSCA REGISTRY AS FOLLOWS: SULFURIC
ACID, LEAD, LEAD OXIDE, LEAD SULFATE, ANTIMONY, ARSENIC, CALCIUM,
TIN
State Regulatory Information:CALIFORNIA PROPOSITION 65: WARNING: THIS
PRODUCT CONTAINS LEAD, A CHEMICAL KNOWN TO THE STATE OF
CALIFORNIA TO CAUSE CANCER, BIRTH DEFECTS OR OTHER REPRODUCTIVE
HARM.
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:560E634 W/B SANDING SEALER
Preparer's Name:ZEKE
CAGE:GO190
CAGE:GO190
CAGE:6D488
============= Composition/Information on Ingredients =============
Ingred Name:2-BUTOXYETHANOL (ETHYLENEGLYCOL MONOBUTYL ETHER), BUTYL
CELLOSOLVE, BUTYL GLYCOL, GLYCOL ETHER EB
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: 8%
Other REC Limits:25 PPM (SKIN)
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM; 9293
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: VAPOR OR MIST CAN CAUSE
HEADACHE, NAUSEA, & IRRITATION OF THE NOSE, THROAT & LUNGS.
SKIN/EYES: IRRITATION. INGESTION: HARMFUL. NAUSEA, VOMITING,
DIARRHEA & GASTROINTESTINAL IRRITATION.
Explanation of Carcinogenicity:NONE
======================= First Aid Measures =======================
First Aid:SKIN: WASH W/SOAP & WATER. INHALATION: REMOVE TO FRESH AIR.
EYES: FLUSH W/WATER FOR AT LEAST 15 MINS. INGESTION: OBTAIN MEDICAL
ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG
Fire Fighting Procedures:WEAR ADEQUATE FIRE FIGHTING EQUIPMENT
INCLUDING A SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:POLYMER FILM CAN BURN. MATERIAL CAN
SPLATTER ABOVE 212F. EXCESS HEAT MAY CAUSE CONTAINERS TO RUPTURE.
================== Accidental Release Measures ==================
Spill Release Procedures:WIPE UP IMMEDIATELY & SAFELY DISCARD
ABSORBENTS. IN THE EVENT OF LARGE SPILLS, DIKE THE AREA & PUMP THE
MATERIAL TO AN EPA PERMITTED WASTE TANK.
======================Handling and Storage ======================
Handling and Storage Precautions:USE ADEQUATE VENTILATION. KEEP AWAY
FROM EXCESSIVE HEAT.
Other Precautions:AVOID PROLONGED BREATHING OF VAPOR. AVOID SKIN & EYE
CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE A NIOSH APPROVED CARTRIDGE RESPIRATOR OR GAS
MASK WHEN SPRAYING. IN POORLY VENTILATED & CONFINED SPACES USE A
FRESH-AIR SUPPLYING RESPIRATOR OR SELF-CONTAINED BREATHING
APPARATUS.
Ventilation:GOOD VENTILATION TO KEEP BELOW TLV VALUES.
Other Protective Equipment:IMPERVIOUS CLOTHING, BOOTS, EYE WASHES,
SAFETY SHOWERS.
Work Hygienic Practices:REMOVE & WASH CONTAMINATED CLOTHES BEFORE
REUSE. USE BARRIER CREAMS, SHOWERS & CHANGE CLOTHES. WASH HANDS
THOROUGHLY.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F WATER
Vapor Density:<1
Spec Gravity:1.0
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:TURBID VISCOUS LIQUID. MILD ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
THAT ARE WATER REACTIVE. STRONG ALKALINE & ACIDIC SUBSTANCES.
Stability Condition to Avoid:AVOID TEMPERATURES <40F, FREEZING
CONDITIONS & ALL SOURCES OF HEAT.
Hazardous Decomposition Products:CO, CO2, ON COMBUSTION
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/FEDERAL, STATE &
LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:5245 VITON CEMENT
Kit Part:Y
Preparer's Name:LARRY W. MINTON
CAGE:48482
CAGE:48482
============= Composition/Information on Ingredients =============
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 60-80%
Other REC Limits:STEL 300 PPM
OSHA PEL:200 PPM/300 STEL
ACGIH TLV:200 PPM/300STEL 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:FLUORO ELASTOMER RESIN
CAS:25190-89-0
Fraction by Wt: 20-25%
Other REC Limits:NONE SPECIFIED
Ingred Name:MAGNESIUM OXIDE
CAS:1309-48-4
RTECS #:OM3850000
Fraction by Wt: 3-4%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10MG/M3 RESPIRABLE
ACGIH TLV:10 MG/M3; FUME; 9192
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: 3-4%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3; 9192
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE-MAY CAUSE
IRRITATION,REDNESS,TEARING,BLURRED VISION. PROLONGED &/OR REPEATED
SKIN CONTACT MAY CAUSE IRRITATION,DEFATTING,DERMATITIS. INHALATION
MAY CAUSE RESPIRATORY IRRITATION, CNS EFFECTS I.E.
DIZZINESS,WEAKNESS,FATIGUE,NAUSEA,HEADACHE,UNCONSCIOUSNESS,DEATH.
CHRONIC-LIVER OR KIDNEY DAMAGE; LUNG & BRAIN DAMAGE.
Explanation of Carcinogenicity:THIS PRODUCT IS NOT CONSIDERED A
CARCINOGEN BY NTP. IARC OR OSHA.
Effects of Overexposure:EYES:SEVERE IRRITATION, REDNESS, TEARING &
BLURRED VISION. SKIN:IRRITATION, DEFATTING & DERMATITIS.
INHALED:NASAL & RESPIRATORY IRRITATION, HEADACHE, DIZZINESS, WEAK,
FATIGUE, POSSIBLE UNCONSCIOUSNES S & ASPHYXIATION. INGESTION:G/I
IRRITATION, VOMITING, DIARRHEA & NAUSEA.
Medical Cond Aggravated by Exposure:MEK MAY SHORTEN THE TIME OF ONSET
OF PERIPHERAL NEUROPATHY CAUSED BY METHYL N- BUTYL KETONE &
N-HEXANE. MEK BY ITSELF HAS NOT BEEN SHOWN TO CAUSE PERIPHERAL
NEUROPATHY.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/LG AMNTS OF WATER, LIFTING LIDS, GET MED ATTN.
SKIN:WASH AREA W/SOAP & WATER. REMOVE CONTAMINATED CLOTHES &
LAUNDER CLOTHES BEFORE REUSE. INHALE:IF AFFECTED, REMOVE TO FRESH
AIR. IF BREAT HING IS DIFF, ADMIN OXYGEN. IF BEATHINGHAS STOPPED,
GIVE CPR. GET MED ATTN IMMED. INGESTION:DO NOT INDUCE VOMITING.
KEEP PERSON WARM/ QUIET & GET MED ATTN. ASPIRATION INTO LUNGS MAY
CAUSE PNEUMONITUS
===================== Fire Fighting Measures =====================
Flash Point:23.0F,-5.0C
Lower Limits:2
Upper Limits:12
Extinguishing Media:ALCOHOL FOAM, CARBON DIOXIDE OR DRY CHEMICALS.
Fire Fighting Procedures:WEAR SELF CONTAINED BREATHING APPARATUS WITH
FULL FACE PIECE IN POSITIVE PRESSURE MODE. WEAR PROTECTIVE CLOTHING
TO PROTECT FROM HYDROGEN FLOURIDE.
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR & MAY TRAVEL
ALONG THE GROUND. IGNITION OF A VAPOR ACCUMULATION MAY CREATE FLASH
OR EXPLOSION.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES. WEAR
PROTECTIVE CLOTHING. ABSORB MIXTURE WITH SAND, CLAY, EARTH, FLOOR
ABSORBENT OR OTHER ABSORBENT MATERIAL & SHOVEL INTO CONTAINERS.
Neutralizing Agent:MFR GAVE NO INFORMATION ON MSDS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY PLACE. KEEP
CONTAINERS TIGHTLY CLOSED WHEN NOT IN USE. DO NOT STORE NEAR HEAT,
SPARKS OR FLAME. GROUND FIXED EQUIPMENT.
Other Precautions:STATIC ELECTRICITY MAY OCCUR & CREATE A FIRE HAZARD.
BOND & GROUND TRANSFER CONTAINERS & EQUIPMENT. EMPTIED CONTAINERS
RETAIN PRODUCT RESIDUES. OBSERVE ALL HAZARD PRECAUTIONS WITH
EMPTIED CONTAINERS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR NIOSH/MSHA APPROVED AIR SUPPLIED
RESPIRATOR, IF MEK VAPOR EXPOSURE LIMITS ARE EXCEEDED.
Ventilation:PROVIDE SUFFICIENT MECHANICAL VENTILATION TO MAINTAIN
EXPOSURE BELOW TLV.
Other Protective Equipment:AVOID REPEATED OR PROLONGED SKIN CONTACT.
WEAR A CHEMICAL RESISTANT APRON.
Work Hygienic Practices:MFR? HMIS:PRACTICE GOOD INDUSTRIAL HYGIENE.
AVOID UNNECESSARY CONTACT. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
ELIMINATE IGNITION SOURCES. DO NOT WELD OR USE A CUTTING TORCH.
================== Physical/Chemical Properties ==================
HCC:F2
NRC/State Lic Num:NONE
Boiling Pt:B.P. Text:175F,79C
Vapor Pres:70 MM
Vapor Density:2.5
Spec Gravity:1.1
pH:N/AP
Evaporation Rate & Reference:5.70 (N-BUTYL ACETATE=1)
Solubility in Water:20%
Appearance and Odor:DARK GRAY OR BLACK, VISCOUS LIQUID WITH SOLVENT
ODOR.
Percent Volatiles by Volume:80 MAX
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID STRONG OXIDIZING AGENTS
Stability Condition to Avoid:COMBUSTION OR TEMPERATURES ABOVE 200 C MAY
CREATE HYDROGEN FLOURIDE.
Hazardous Decomposition Products:HYDROGEN FLUORIDE,TOXIC FLOUROCARBON
OLEFINS,CO2,CO,VARIOUS HYDROCARBONS MAY EVOLVE DURING COMBUSTION OR
TEMP ABOVE 200C
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF I/A/W FEDERAL, STATE & LOCAL
REGULATIONS. INCINERATION REQUIRES SCRUBBING OF GASEOUS PRODUCTS TO
REMOVE HYDROGEN FLOURIDE.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:EC-2241
CAGE:76381
CAGE:76381
============= Composition/Information on Ingredients =============
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 25.0%
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 35.0%
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:N-BUTYL ALCOHOL (SARA III)
CAS:71-36-3
RTECS #:EO1400000
Fraction by Wt: 10.0%
OSHA PEL:100 PPM
ACGIH TLV:S, C 50 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ORGANIC TIN COMPOUND
Fraction by Wt: 02.0%
OSHA PEL:S, 0.1 MG/M3 (SN)
ACGIH TLV:S, 0.1 MG/M3 (SN)
===================== Hazards Identification =====================
Effects of Overexposure:EYE SKIN LUNG IRRITANT
======================= First Aid Measures =======================
First Aid:EYES;FLUSH IMMEDIATELY WITH PLENTY OF WATER-SEEK MEDICAL
ATTENTION. SKIN: WASH WITH SOAP & WATER. INHALATION: PROVIDE FRESH
AIR.
===================== Fire Fighting Measures =====================
Flash Point:40F(4.4C) CC
Lower Limits:1.00
Upper Limits:7.00
Extinguishing Media:CO2, FOAM, DRY CHEMICALS.
================== Accidental Release Measures ==================
Spill Release Procedures:EXTINGUISH IGNITION SOURCES. COLLECT SPILLED
MATERIAL CLEANUP RESIDUE
============= Exposure Controls/Personal Protection =============
Ventilation:LOCAL EXHAUST
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:231F=110.6C
Vapor Pres:028
Vapor Density:03.5
Spec Gravity:1.0000
Evaporation Rate & Reference:9.0 ETHER
Solubility in Water:SLIGHT
Appearance and Odor:WHITE, SOLVENT ODOR
Percent Volatiles by Volume:70.0
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE PROPERLY. DO NOT LANDFILL.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:S07300 SODIUM TELLURITE
CAGE:93272
CAGE:93272
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM TELLURITE (SARA 302)
CAS:10102-20-2
RTECS #:WY2450000
Fraction by Wt: 100%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.1 MG(TE)/M3
ACGIH TLV:0.1 MG(TE)/M3; 9596
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT) IS 85 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TOXIC BY INHALATION AND INGESTION.
EXTREMELY IRRITATING TO SKIN AND EYES.
Explanation of Carcinogenicity:THIS PRODUCT IS NOT LISTED BY IARC, NTP
OR OSHA AS A CARCINOGEN, MUTAGEN, TERATOGEN OR NEUROTOXIN.
Effects of Overexposure:TOXIC BY INHALATION AND INGESTION. EXTREMELY
IRRITATING TO SKIN AND EYES.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES-FLUSH WITH WATER FOR AT LEAST 10 MINUTES. GET MEDICAL
ATTENTION. SKIN-REMOVE CONTAMINATED CLOTHES. WASH WITH MILD SOAP &
WATER. GET MEDICAL ATTENTION. INHALED-REMOVE TO FRESH AIR, REST &
KEEP WAR M. IN SEVERE CASES, GET MEDICAL ATTENTION. INGESTED-IF
CONSCIOUS, RINSE OUT MOUTH & GIVE PLENTY OF WATER TO DRINK. GET
IMMEDIATE MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Extinguishing Media:NONE SPECIFIED BY MANUFACTURER. DLA-HMIS: USE MEDIA
APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures:NOT APPLICABLE. DLA-HMIS: WEAR SELF-CONTAINED
BREATHING APPARATUS AND FULL FIRE FIGHTER'S PROTECTIVE GEAR.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR APPROPRITATE PERSONAL PROTECTIVE
CLOTHING. MIX WITH SAND, TRANSFER CAREFULLY AND ARRANGE REMOVAL BY
DISPOSAL COMPANY. WASH SITE THOROUGHLY WITH WATER & DETERGENT. IF
MATERIAL HAS ENTERED SURFACE DRAINS, INFORM LOCAL AUTHORITIES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NO SPECIAL REQUIREMENTS.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:DUST RESPIRATOR.
Ventilation:EXTRACTION HOOD.
Other Protective Equipment:PLASTIC APRON, SLEEVES, BOOTS-IF HANDLING
LARGE QUANTITIES. DLA-HMIS: EYE WASH STATION & SAFETY SHOWER.
Work Hygienic Practices:WASH HANDS AFTER HANDLING AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:T4
Solubility in Water:SLIGHT
Appearance and Odor:WHITE, DELIQUESCENT CRYSTALS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER-GIVES STRONGLY ALKALINE SOLUTIONS.
Stability Condition to Avoid:STABLE IF KEPT DRY.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL ENVIRONMENTAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ETHYL ACETIMIDATE HYDROCHLORIDE, E3880
CAGE:21076
CAGE:21076
============= Composition/Information on Ingredients =============
Ingred Name:ETHYL ACETIMIDATE HYDROCHLORIDE
CAS:2208-07-3
= Wt:100.
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: MAY BE HARMFUL BY INHALATION,
INGESTION, OR SKIN ABSORPTION. CAUSES EYE AND SKIN IRRITATION.
MATERIAL IS IRRITATING TO MUCOUS MEMBRANES AND UPPER RESPIRATORY
TRACT.
Effects of Overexposure:SEE HEALTH HAZARDS.
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH WITH COPIOUS AMOUNTS OF WATER FOR AT
LEAST 15 MINUTES. SKIN: FLUSH WITH WATER. INHALATION: REMOVE TO
FRESH AIR. INGESTION: WASH OUT MOUTH WITH WATER PROVIDED PERSON IS
CONSCIOU S. CALL A PHYSICIAN.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL POWDER OR
APPROPRIATE FOAM.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:EMITS TOXIC FUMES UNDER FIRE CONDITIONS.
================== Accidental Release Measures ==================
HOLD FOR WASTE DISPOSAL. AVOID RAISING DUST. VENTILATE AREA AND
WASH SPILL SITE AFTER MATER IAL PICKUP IS COMPLETE.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID BREATHING DUST. AVOID CONTACT
WITH EYES, SKIN AND CLOTHING. IRRITANT. KEEP TIGHTLY CLOSED.
MOISTURE SENSITIVE. STORE IN A COOL DRY PLACE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR NIOSH APPROVED DUST MASK.
Ventilation:MECHANICAL EXHAUST REQUIRED.
Other Protective Equipment:EYE WASH AND DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA .
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:>112.C, 233.6F
Appearance and Odor:WHITE CRYSTALS WITH CHUNKS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS. STRONG BASES. MAY DECOMPOSE ON EXPOSURE TO
MOIST AIR OR WATER.
Hazardous Decomposition Products:HAZARD COMBUSTION OR DECOMPOSITION
PRODUCTS TOXIC FUMES OF: CARBON MONOXIDE, CARBON DIOXIDE, NITROGEN
OXIDES, HYDROGEN CHLORIDE GAS.
=================== Toxicological Information===================
Toxicological Information:TO THE BEST OF MFR'S KNOWLEDGE, THE CHEMICAL,
PHYSICAL, AND TOXICOLOGICAL PROPERTIES HAVE NOT BEEN THOROUGHLY
INVESTIGATED.
===================== Ecological Information =====================
Ecological:DATA NOT YET AVAILABLE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISSOLVE OR MIX THE MATERIAL WITH A COMBUSTIBLE
SOLVENT AND BURN IN A CHEMICAL INCINERATOR EQUIPPED WITH AN
AFTERBURNER AND SCRUBBER. OBSERVE ALL FEDERAL, STATE AND LOCAL
ENVIRONMENTAL REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:CONTACT SIGMA CHEMICAL COMPANY FOR TRANSPORTATION
INFORMATION.
===================== Regulatory Information =====================
Federal Regulatory Information:EUROPEAN INFORMAITON: IRRITANT R
36/37/38 IRRITATING TO EYES, RESPIRATORY SYSTEM AND SKIN. S 26 IN
CASE OF CONTACT WITH EYES, RINSE IMMEDIATELY WITH PLENTY OF WATER
AND SEEK MEDICAL ADVICE. S 36 WEARSUITABLE PROTECTIVE CLOTHING.
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:PLASTIC AND DISPLAY INKS, C-33-5O NL BRILLIANT BLUE
CAGE:07146
CAGE:07146
============= Composition/Information on Ingredients =============
Ingred Name:ING 5:SKIN ABSORP, MAY CAUSE ADVERSE EFTS ON BLOOD, GI,
NERVOUS AND REPRODUCTIVE SYSTEMS.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC:IN SAFE USE OF PROD. DISP OF EMPTIED CNTNRS IN
ACCORD W/LOCAL, STATE, & FED REGS. ALL HAZ PREC GIVEN (ING 6)
RTECS #:9999999ZZ
Other REC Limits:NONE RECOMMENDED
Ingred Name:ING 5:IN THIS DATA SHEET MUST BE OBSERVED WHEN DISPOSING OF
CONTAINERS HOLDING RESIDUAL MATERIAL.
RTECS #:9999999ZZ
Ingred Name:VENT:USE NIOSH/MSHA APPROVED CARTRIDGE RESPIRATOR OR GAS
MASK.
RTECS #:9999999ZZ
Ingred Name:ETHANOL, 2-BUTOXY-; (BUTYL CELLOSOLVE) LEL:1.1%. VP:0.6
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: 26%
OSHA PEL:25 PPM, S
ACGIH TLV:25 PPM, S
Ingred Name:2-PENTANONE, 4-HYDROXY-4-METHYL-; (DIACETONE ALCOHOL).
LEL:1.8%. VP:<1
CAS:123-42-2
RTECS #:SA9100000
Fraction by Wt: 45%
OSHA PEL:50 PPM
ACGIH TLV:50 PPM
Ingred Name:SUPP DATA:REPEATED EXPOSURE THROUGH INGEST, INHALATION OF
AIRBORNE PARTICULATES AND TO MUCH LESSER DEGREE (ING 4)
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:"ANIMAL STUDIES CLEARLY DEMONSTRATED
DOSE- RELATED ADVERSE EFTS ON CNS, HEMATOPOIETIC TISS, BLOOD,
KIDNEYS & LIVER ASSOC W/ADMIN OF ETHYLENE GLYCOL MONOBUTYL ETHER
(EGBE). (EXTRACTED FROM DHHS (NIOSH) PUB NO. 90-118). ".
ACUTE:EYE: MAY CAUSE IRRITATION. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:SKIN:MAY CAUSE IRRIT W/PRLNGD/RPTD
CNTCT. ABSORPTION MAY OCCUR THRU INTACT SKIN. AVOID &/OR MINIMIZE
CNTCT BY MAINTAINING HIGH STANDARDS OF INDUSTRIAL HYGIENE.
INHAL:OVEREXPOS TO HIGH CONC MA Y CAUSE RESP TRACT IRRIT, NAUS,
DIZZ, &NARCOSIS. CHRONIC:PRLNGD/ RPTD EXPOS TO 2-BUTOXYETHANOL MAY
CAUSE (SUPP DATA)
Medical Cond Aggravated by Exposure:PRE-EXISTING EYE, SKIN,
RESPIRATORY, KIDNEY AND LIVER DISORDERS.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH EYES W/LG QTYS OF WATER FOR AT LEAST 15 MIN. SEEK
IMMED MED ASSIST. SKIN CNTCT:WASH IMMED W/LG QTYS OF WATER & MILD
SOAP. IF IRRIT PERSISTS OR OTHER EFTS, SEEK IMMED MED ATTN.
INHAL:IF BRTH G DFCLT, DIZZ, OR LIGHTHEADEDNESS OCCURDUE TO
OVEREXPOS, REMOVE PERSON FROM EXPOS. IF BRTHG IS DFCLT, GIVE
OXYGEN. IF BRTHG STOPS, BEGIN ARTF RESP. SEEK IMMED MED AID.
INGEST:CNTCT MD IMMED.
===================== Fire Fighting Measures =====================
Flash Point:117F,47C
Lower Limits:1.1%
Extinguishing Media:FOAM, CO2, DRY CHEMICAL, WATER SPRAY.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP.
WATER MAY BE UNSUITABLE AS AN EXTING MEDIA, BUT HELPFUL IN KEEPING
ADJACENT CNTNRS COOL. AVOID (SUPP DATA)
Unusual Fire/Explosion Hazard:WITH THE PRESENCE OF IGNITABLE MATERIALS,
KEEP WORK AREAS FREE OF HOT METAL SURFACES AND OTHER SOURCES OF
IGNITION.
================== Accidental Release Measures ==================
Spill Release Procedures:W/PRESENCE OF IGNITABLE MATERIALS, AVOID HOT
METAL SURFACES AND OTHER SOURCES OF IGNITION. AVOID OVEREXPOS.
SPILL SHOULD BE CONTAINED, AND GATHERED INTO SUITABLE RETAINING
AREA. SMALL AMOUNTS OF LIQUI D SPILLS MAY BE ABSORBED INTO APPROP
ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CNTNRS COOL, DRY & AWAY FROM
IGNIT SOURCES. SEE OSHA REGS, PARTICULARLY OSHA 1910.106 FOR INFO
ON FLAMM & COMBUSTIBLES. FOR INDUSTRIAL USE ONLY.
Other Precautions:USE & STORE W/ADEQ VENT. KEEP CNTNRS CLSD WHEN NOT IN
USE. AVOID INHAL. DO NOT TAKE INTERNALLY. AVOID PERS CNTCT. SHOULD
CNTCT BE MADE, REMOVE SATURATED CLTHG & WASH AFFECTED AREAS. KEEP
OUT OF REACH OF CHILDREN & OTHERS NOT TRAINED (ING 5)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED WITH ADEQUATE VENT. HOWEVER, IF
VAPOR CONCENTRATION EXCEEDS TIME-WEIGHTED TLV OR PERMISSIBLE
LIMITS, USE NIOSH/ MSHA APPROVED CARTRIDGE RESPIRATOR OR GAS MASK.
Ventilation:LOCAL EXHAUST PREF. MINIMIZE EXPOS TO LOWEST PRACTICAL
LEVEL BELOW TIME-WEIGHTED TLV & PERMISSIBLE EXPOS LIMITS, (ING 7)
Other Protective Equipment:EYE BATH, SAFETY SHOWER, PROTECTIVE
CLOTHING. THE USE OF A SUITABLE BARRIER CREAM MINIMIZES EFFECTS OF
SKIN CONTACT.
Work Hygienic Practices:WASH THOROUGHLY WITH MILD SOAP AND WATER AFTER
HANDLING. WASH CLOTHING BEFORE RE-USE.
Supplemental Safety and Health
FIRE FIGHT PROC:SPREADING BURING MATL WITH WATER USED FOR COOLING. EFTS
OF OVEREXP:IMPAIRED LUNG FUNCTION, BLOOD DISORDERS, LIVER & KIDNEY
DAMAGE. (ING 3)
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:>335F,>168C
Vapor Density:HVR/AIR
Spec Gravity:0.96-1.32
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:30-70
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG ACIDS OR BASES.
Stability Condition to Avoid:HEAT, SPARKS, FLAME.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY YIELD CO,
CO2, AND POSSIBLY OTHER TOXIC FUMES/VAPORS.
Conditions to Avoid Polymerization:HEAT, TEMPERATURE EXTREMES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE, AND
FEDERAL REGULATIONS .
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:O-C-303,CHROMIUM TRIOXIDE TECHNICAL
CAGE:KO980
CAGE:KO980
CAGE:1L164
============= Composition/Information on Ingredients =============
Ingred Name:CHROMIC ACID,SOLID
CAS:117-10-2
RTECS #:CB6650000
Fraction by Wt: >99%
ACGIH TLV:0.05 MG/CUM(CR)
===================== Hazards Identification =====================
Effects of Overexposure:STRONG IRRITATION OF SKIN & MUCOUS
MEMBRANES.DERMATITIS,CHROME ULCER,LOSS OF EYESIGHT,CHROME HOLE
======================= First Aid Measures =======================
First Aid:FLUSH WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES.GET
IMMEDIATE MEDICAL ATTENTION FOR EYES & SKIN BURNS OR IF INGESTED OR
INHALED REMOVE TO UNCONTAMINATED AREA & GET IMMEDIATE MEDICAL
ATTENTION.WASH CONTAMINATED AREAS OF BODY WITH LARGE AMOUNTS H*2O
===================== Fire Fighting Measures =====================
Flash Point:N.A.
Extinguishing Media:WATER
Fire Fighting Procedures:FLUSH WITH WATER
Unusual Fire/Explosion Hazard:POWERFUL OXIDIZING AGENT.MAY IGNITE
OXIDIZABLE MATERIALS.KEEP AWAY FROM COMBUSTIBLES,E.G;PAPER,WOOD.
================== Accidental Release Measures ==================
Spill Release Procedures:COVER WITH WEAK REDUCING AGENTS SUCH AS
HYPO,BISULFITES OR FERROUS SALTS-BISULFITES OR FERROUS SALTS NEED
ADDITIONAL PROMOTER OF SOME 3M-H*2SO*4 FOR RAPID REACTION.TRANSFER
THE SLURRY INTO A LARGE CON TANER OF WATER,NEUTRALIZE WITH SODA
ASH.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN DRY AREA WITH TIGHTLY CLOSED
STEEL CONTAINERS OUT OF CONTACT WITH COMBUSTIBLES OR ORGANICS SUCH
AS GREASES.AVOID WOOD FLOORING.
Other Precautions:PROTECT CONTAINERS AGAINST PHYSICAL DAMAGE,WEAR
CONTAINED BREATHING APPARATUS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:U.S.BUREAU OF MINES 2175 MODEL 7100 DUST
RESPIRATOR
Ventilation:ADEQUATE TO REMOVE DUST OR MISTS.
Other Protective Equipment:FACE SHIELD,RUBBER SLEEVES,APRONS,BOOTS,HARD
HATS,CLOTHING
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:D3
NRC/State Lic Num:NOT RELEVANT
Spec Gravity:2.7
Solubility in Water:APPRECIABLE
Appearance and Odor:SOLID,DARK RED FLAKES OR POWDER,NO ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
COMBUSTIBLES & MANY ORGANICS,REDUCING AGENTS,OILS,GREASES.
Stability Condition to Avoid:EXPOSURE TO MOIST AIR PICKS UP WATER
Hazardous Decomposition Products:AT 387F.OXYGEN GAS & CHROMIC OXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:USE VAST VOLUME OF CONCENTRATED SOLUTION OF
REDUCING AGENT(BISULFITES OR FERROUS SALTS WITH 3M-H*2SO*4 OR
HYPO).NEUTRALIZE WITH SODA ASH OR DILUTE HCL.DRAIN INTO AN APPROVED
DISPOSAL AREA.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:FAULT FINDER CLEANER GROUP 1 #1071,PART B
Kit Part:Y
Preparer's Name:ROBERT E. BAYTON,LAB SUPV
CAGE:92381
CAGE:92381
============= Composition/Information on Ingredients =============
Ingred Name:ISOPROPYL ALCOHOL (SARA III)
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 51-70%
Other REC Limits:NONE SPECIFIED
OSHA PEL:400 PPM/500 STEL
ACGIH TLV:400 PPM/500STEL;9192
Ingred Name:HYDROCARBON PROPELLANT
CAS:68476-86-8
Fraction by Wt: 11-30%
Other REC Limits:NONE SPECIFIED
OSHA PEL:900 PPM
ACGIH TLV:900 PPM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: MILD IRRITATION TO BODY
TISSUES. CENTRAL NERVOUS SYSTEM DEPRESSION. CHRONIC: PROLONGED
EXPOSURE MAY RESULT IN KIDNEY AND LIVER DAMAGE.
Effects of Overexposure:EYES: MODERATELY IRRITATING. SKIN: MILDLY
IRRITATING. INHALATION: MILD IRRITATION TO NOSE, THROAT AND
RESPIRATORY TRACT. MAY RESULT IN CENTRAL NERVOUS SYSTEM DEPRESSION.
INGESTION: NONE NOTED BY MANUF ACTURER.
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH A HISTORY OF EYES,
RESPIRATORY OR SKIN ALLERGIC CONDITIONS MAY BE AT INCREASED RISK.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH WITH PLENTY OF WATER FOR 15 MINUTES.IF IRRITATION
PERSISTS SEE DOCTOR. SKIN:WASH WITH SOAP AND WATER.IF IRRITATION
PERSISTS.SEE DOCTOR. INHALATION:REMOVE TO FRESH AIR.GIVE OXYGEN/CPR
IF NEE DED,SEE DOCTOR. INGESTION: DO NOT INDUCE VOMITING. DRINK
PLENTY OF WATER. SEE DOCTOR.
===================== Fire Fighting Measures =====================
Flash Point:N/R, AEROSOL
Lower Limits:1.8
Upper Limits:9.5
Extinguishing Media:CARBON DIOXIDE, FOAM, OR DRY CHEMICAL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. EVACUATE AREA. COOL
FIRE EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:CONTENTS UNDER PRESSURE. CONTAINER MAY
EXPLODE ON HEAT OF FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE IGNITION SOURCES.EVACUATE
PERSONNEL.VENTILATE.WEAR RESPIRATOR AND PROTECTIVE CLOTHING.ABSORB
IN INERT MATERIAL AND PLACE IN APPROPIATE DISPOSAL CONTAINER.WASH
AREA WITH SOAP AND WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE IN DIRECT SUNLIGHT, NEAR
OPEN FLAMES, OR AT TEMPERATURES EXCEEDING 120F. DO NOT SMOKE WHILE
SPRAYING.
Other Precautions:USE ONLY AS DIRECTED. INTENTIONAL MISUSE BY
DELIBERATELY CONCENTRATING VAPORS AND INHALING CONTENTS CAN BE
HARMFUL OR FATAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA-APPROVED RESPIRATOR APPROPIATE FOR
EXPOSURE OF CONCERN IF TLV IS EXCEEDED.
Ventilation:LOCAL EXHAUST TO MAINTAIN EXPOSURE BELOW TLV.
Other Protective Equipment:PROTECTIVE CLOTHING AND EQUIPMENT AS
REQUIRED TO PREVENT PROLONGED CONTACT.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. LAUNDER
CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
KEY1:F1. THIS IS PART B OF A 3-PART PRODUCT. FOR OTHER PARTS, SEE PNI A
AND C, SAME NSN. THIS NSN HAS BEEN CANCELLED, AND REPLACED WITH NSN
6850-00-142-8840.
================== Physical/Chemical Properties ==================
HCC:V3
Boiling Pt:B.P. Text:174F,79C
Vapor Pres:45 PSIG
Vapor Density:>1
Spec Gravity:<1
Evaporation Rate & Reference:<1 (ETHER = 1)
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, WATER WHITE LIQUID. ETHEREAL ODOR.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAMES, ELECTRICAL
ARCS.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
UNINDENTIFIED ORGANIC COMPOUNDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTACT YOUR LOCAL ENVIRONMENTAL OFFICER.DO NOT
PUNCTURE OR INCINERATE CONTAINER. DISPOSE OF IN ACCORDANCE WITH
FEDERAL,STATE AND LOCAL ENVIRONMENTAL REGULATIONS. FULL OR
PARTIALLY FILLED CONTAINERS A RE CONSIDERED HAZARDOUS WASTE.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:70-001 BRKTHRU GLOSS-WHITE 701
Preparer's Name:ELAINE CREADORE
CAGE:VANEX
CAGE:VANEX
============= Composition/Information on Ingredients =============
Ingred Name:SUPP DATA: DHHS (NIOSH) PUB # 90-118 .
RTECS #:9999999ZZ
Ingred Name:FIRST AID:SYMPTOMS DEVELOP. CONSULT MS.
RTECS #:9999999ZZ
Other REC Limits:NONE SPECIFIED
Ingred Name:DIBUTYL PHTHALATE (SARA III)
CAS:84-74-2
RTECS #:TI0875000
Fraction by Wt: <5.0%
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3; 9192
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:2-BUTOXYETHANOL
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: 10%
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM; 9293
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL OF HIGH CONC OF VAP CAN INDUCE
ANEMIA/ LIVER/KIDNEY INJURY & CLOUDING OF CORNEA. VAP OF MATL MAY
IRRIT NOSE/ THROAT/RESP PASSAGES. HIGHER CONC CAN INDUCE HDCH,
DIZZ, NAUSEA, DROWSINESS, & SHORTN ESS OF BREATH. SKIN: NO IRRIT IS
LIKELYTO DEVELOP FOLLOWING SHORT CONT PERIODS W/HUMAN SKIN.
PRLNG/RPTD (EFTS OF OVEREX
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:EXPOS CAN LEAD TO REDNESS/SWELLING/
NECROSIS. EYE: MATL CAN INDUCE PAIN & MODERATE IRRIT. SKIN
ABSORP:ADVERSE SYSTEMIC EFTS CAN DEVELOP FOLLOWING RPTD/PRLNG CNTCT
W/HUMAN SKIN. INGEST: SINGLE DOSE OF PROD IS MODERATELY TOX BY
INGEST. ANIMAL STUDIES CLEARLY DEMONSTRATE DOSE-RELATED ADVERSE
EFTS ON THE(SUPP DATA
Medical Cond Aggravated by Exposure:LUNG DISEASES.
======================= First Aid Measures =======================
First Aid:SKIN:REMOVE CONTAMD CLTHG/FOOTWEAR. WASH MATL OFF SKIN W/SOAP
& H2O. IF RED/ITCH/BURN SENSATION DEVELOPS, GET MED ATTN. WASH
CONTAMD CLTHG & DECONTAMINATE FOOTWEAR BEFORE REUSE. EYES:IMMED
FLUSH W/H2O FOR @ LST 15 MIN & HAVE EYES EXAMINED & TREATED BY MED
PERSL. INGEST:GIVE 1 OR 2 GLASSES OF H2O TO DRINK. INDUCE VOMIT.
REFER TO MED PERS. INHAL:REMOVE TO FRESH AIR. IF COUGH OR OTHER
RESP(ING 04)
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:210F,99C
Lower Limits:0.5%
Upper Limits:10.6%
Extinguishing Media:ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED POSITIVE-PRESSURE
SCBA AND FULL PROTECTIVE EQUIPMENT.
Unusual Fire/Explosion Hazard:NO UNUSUAL FIRE/EXPLOSION ARE KNOWN FOR
THIS PRODUCT. AS TYPICAL OF CLOSED CONTAINERS CONTAINING LIQUID,
THEY MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:DIKE AND CONTAIN SPILL WITH INERT MATERIALS
(SAND/CLAY/EARTH/ETC.). TRANSFER LIQUID TO CONTAINERS FOR RECOVERY
OR DISPOSAL. KEEP SPILL OUT OF SEWERS AND OPEN BODIES OF WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP FROM FREEZING. KEEP AWAY FROM
HEAT/OPEN FLAME. AVOID BRTHG VAP. AVOID CONT W/EYES/SKIN/CLTHG. USE
W/VENT ADEQ TO MAINTAIN VAP CONC BELOW(SUPDAT)
Other Precautions:SUBJECT TO REPORTING REQUIREMENTS UNDER SECTION 313
OF SARA TITLE III & OF 40 CFR 372.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF TLV OF PRODUCT OR ANY COMPONENT IS EXCEEDED,
USE A NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:PROVIDE GENERAL AND/OR LOCAL EXHAUST VENTILATION TO CONTROL
AIRBORNE LEVELS BELOW EXPOSURE GUIDELINES.
Other Protective Equipment:IMPERVIOUS CLOTHING AND SHOES.
Work Hygienic Practices:REMOVE CONTAMINATED CLOTHING IMMED. WASH SKIN
AREA WITH SOAP AND WATER. LAUNDER CLOTHES BEFORE REUSE.
Supplemental Safety and Health
HNDLG/STOR PREC: TLV. CNTNRS OF PROD MAY BE HAZ WHEN EMPTIED-ALL HAZ
PREC MUST BE OBSERVED. KEEP OUT OF REACH OF CHILDREN. EFTS OF
OVEREXP: CNS, HEMATOPOIETIC TISSUES/BLOOD/KIDNEYS & LIVER, ASSOC
W/AD MIN OF ETHYLENE GLYCOL MONOBUTYL ETHER (EGBE) & ETHYLENE
GLYCOL MONOBUTYL ETHER ACETATE (EGBEA). (EXTRACTED FROM (ING 3)
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:SEE INGRED
Vapor Density:>AIR
Spec Gravity:1.3
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:MISCIBLE
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS.
Stability Condition to Avoid:EXCESSIVE HEAT.
Hazardous Decomposition Products:COMBUSTION PRODUCTS:CARBON DIOXIDE,
CARBON MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE
AND FEDERAL REQUIREMENTS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ANTIFOAM
CAGE:86167
CAGE:86167
============= Composition/Information on Ingredients =============
Ingred Name:NON HAZARDOUS INGREDIENTS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NO ADVERSE ACUTE OR CHRONIC EFFECTS
ARE EXPECTED WHEN USED AS RECOMMENDED.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:THIS PRODUCT IS NOT A PRIMARY SKIN IRRITANT;
HOWEVER, SKIN IRRITATION MAY OCCUR IF USED IMPROPERLY (CONCENTRATE
OR MIX).
Medical Cond Aggravated by Exposure:MAY AGGRAVATE EXISTING SKIN
IRRITATION WHERE FURTHER DEFATTING OR SKIN PENETRATION COULD OCCUR.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH IMMEDIATELY WITH RUNNING WATER FOR AT LEAST 15
MINUTES, THEN GET MD TO CHECK FOR POSSIBLE IRRITATION. SKIN:WASH
IMMEDIATELY WITH SOAP & WATER. INGEST:DO NOT INDUCE VOMITING.
DILUTE WITH WATE R OR MILK. CALL MD IMMEDIATELY. INHAL:MOVE TO
FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTF RESP) .
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:NONE
Extinguishing Media:NO FIRE HAZARD. USE MEDIA SUITABLE FOR SURROUNDING
FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:THOROUGHLY FLUSH WITH WATER TO SEWER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID ALL CONTACT OF CONC W/EYES OR
PRLNGD CONTACT W/SKIN. DO NOT SWALLOW. IF FROZEN, PRODUCT
SEPARATES. THAW COMPLETELY AT ROOM TEMP & STIR THORO.
Other Precautions:USE ONLY AS RECOMMENDED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:GENERAL.
Other Protective Equipment:EFFECTIVE METALWORKING PLANT PROTECTIVE
CLOTHING AS APPROPRIATE.
Work Hygienic Practices:GOOD PERSONAL HYGIENE SHOULD ALWAYS BE
FOLLOWED.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:1.000 (H*2O=1)
Evaporation Rate & Reference:<1 (BUTYL ACETATE=1)
Solubility in Water:<0.1%
Appearance and Odor:OPAQUE; CHEMICAL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT OF CONCENTRATE WITH STRONG ACIDS AND BASES.
Stability Condition to Avoid:NOT APPLICABLE.
Hazardous Decomposition Products:NONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:MAY BE DISPOSED OF BY ULTRAFILTRATION, OR
ACID-ALUM-POLYMER CHEMICAL TREATMENT, OR HIGH TEMPERATURE
INCINERATION. DISPOSE OF I/A/W FEDERAL, STATE AND LOCAL REGULATIONS
.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:MAGNATAC M611
Kit Part:Y
CAGE:5B981
CAGE:5B981
============= Composition/Information on Ingredients =============
Ingred Name:3-DIETHYLAMINOPROPYLAMINE (SARA 313)
CAS:104-78-9
RTECS #:TX7350000
Fraction by Wt: >99%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 ORAL RAT=1410MG/KG;DERML RABBIT=750
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN/EYE CONTACT RESULTS IN STRONG
IRRITATION & BURNS. PERMANENT EYE DAMAGE MAY RESULT. INGESTION MAY
RESULT ;IN SEVERE GASTRIC DISTURBANCES, INCLUDING NAUSEA &
VOMITING. INHALATION OF VAPORS/MISTS MA Y RESULT IN RESPIRATORY
IRRITATION.
======================= First Aid Measures =======================
First Aid:EYES: IMMED WASH W/RUNNING WATER 15 MIN. GET IMMEDIATE MED
AID. SKIN: WASH W/WATER WHILE REMOVING CONTAM CLOTHES. GET IMMED
MED AID. LAUNDER CONTAM CLOTHES BEFORE REUSE. INGESTION: DON'T
INDUCE VOMITI NG. DILUTE Q/WATER OR MILK & CALL DR. IMMEDIATELY.
NEVER GIVE FLUIDS OR INDUCE VOMITING IF VICTEM UNCONSCIOUS/HAVING
CONVULSIONS. INHAL: GET FRESH AIR. AID IN BREATHING IF NECESSARY,
GET IMMED MED AID
===================== Fire Fighting Measures =====================
Flash Point:124F,51C
Autoignition Temp:Autoignition Temp Text:215C
Lower Limits:1.4
Upper Limits:11
Extinguishing Media:FOAM, CO2, DRY CHEMICAL.
Fire Fighting Procedures:FIREFIGHTERS SHOULD WEAR SCBA & TURN OUT GEAR.
Unusual Fire/Explosion Hazard:MODERATE, WHEN EXPOSED TO HEAT OR FLAMES.
CAN REACT W/OXIDIZING MATERIALS.
================== Accidental Release Measures ==================
Spill Release Procedures:SPILL SHOULD BE CONTAINED, SOLIDIFIED, PLACED
IN SUITABLE CNTNRS FOR DISPOSAL IN RCRA LICENSED FACILITY. MAT'L IS
RCRA HAZARDOUS DUE TO PROPERTIES.
======================Handling and Storage ======================
Other Precautions:EMPTY CNTNRS W/<1 INCH RESIDUE MAY BE LANDFILLED AT
LICENSED FACILITY. RECOMMEND CRUSHING OR OTHER MEANS TO PREVENT
UNAUTHORIZED REUSE. OTHER CNTNRS MUST BE DISPOSED OF IN RCRA
LICENSED FACILITY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:APPROVED ORGANIC VAPOR RESPIRATOR.
Ventilation:LOCAL EXHAUST TO CONTROL RECOMMENDED PEL.
TO PREVENT SKIN CONTACT.
Supplemental Safety and Health
KEY1:F7. THIS RECORD WAS COPIED FROM A GSA RECORD IN ORDER TO ADD THE
HCC AND TO CHANGE THE SHIPPING DATA FOR THE DLA DEPOT. THIS IS
PART "B" OF A KIT.
================== Physical/Chemical Properties ==================
HCC:F7
Boiling Pt:B.P. Text:155 TO 173C
Vapor Pres: 25 @ 70C
Vapor Density:4.4 AIR=1
Spec Gravity:0.5264
Solubility in Water:MISCIBLE
Appearance and Odor:COLORLESS LIQUID, AMMONIACAL ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACID CHLORIDES, ANHYDRIDES & ISOCYANATES.
Stability Condition to Avoid:CORROSIVE TO METAL
Hazardous Decomposition Products:CO, CO2 & NOX.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE IN AN RCRA LICENSED FACILITY. DO NOT
DISCHARGE INTO WATERWAYS OR SEWERS W/O PROPER AUTHORITY. HAZ WASTE
40 CFR 261. WASTE #D-001, D-002.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:PRIMER-006 OATEY CLEAR PRIMER-NSF, 30750-4
Preparer's Name:GABRIELLA BITZ
CAGE:53472
CAGE:53472
============= Composition/Information on Ingredients =============
Ingred Name:2-BUTANONE; (METHYL ETHYL KETONE)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 70-75%
OSHA PEL:200 PPM;300 PPM STEL
ACGIH TLV:200 PPM;300 PPM STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TETRAHYDROFURAN
CAS:109-99-9
RTECS #:LU5950000
Fraction by Wt: 10-15%
OSHA PEL:200 PPM;250 PPM STEL
ACGIH TLV:200 PPM;250 PPM STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ACETONE
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: < 1%
OSHA PEL:1000PPM
ACGIH TLV:750PPM/1000STEL;9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:CYCLOHEXANONE
CAS:108-94-1
RTECS #:GW1050000
Fraction by Wt: 15-20%
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL:MAY CAUSE IRRIT OF MUC MEMB,
NOSE & THROAT, HDCH, DIZZ, NAUS, NUMBNESS OF EXTREMITIES & NARCOSIS
IN HIGH CONC. HAS CAUSED CNS DEPRESSION & LIVER DMG IN ANIMALS, &
CONC OF 1000-3000 PPM CAUSED R ETARDATION OF FETAL DEVELOPMENT IN
RATS. SKIN:CHRONIC CNTCT MAY LEAD TO IRRIT & DERM. CHRONIC EXPOS
(EFTS OF OVREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: TO VAPS OF HIGH CONC MAY CAUSE DERM.
MAY POSSIBLY BE ABSORBED THROUGH THE SKIN. EYES: VAPORS OR DIRECT
CONTACT MAY CAUSE IRRIT. INGEST: MAY BE ASPIRATED INTO THE LUNGS OR
CAUSE SYSTEMIC EFFE CTS DESCRIBED UNDER INHALATION. TARGET ORGANS:
EYE, SKIN, LUNG, CENTRAL NERVOUS SYSTEM.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:SKIN:WASH THORO W/SOAP & H*2O. SEEK MED ATTN IF IRRIT
PERSISTS. EYES:MOVE TO FRESH AIR & IRRIGATE W/H*2O FOR @ LST 15
MIN. IF IRRIT PERSISTS, SEEK MED ATTN. IF EYE IS STRUCK W/WIRE,
SEEK MED ATTN. INH AL:MOVE TO FRESH AIR.IF BRTHG IS DFCLT,GIVE O*2.
IF NOT BRTHG, GIVE ARTF RESP. KEEP VICTIM QUIET & WARM. CALL A POIS
CNTRL CNTR/MD IMMED. INGEST: DRINK H*2O & CALL POIS CTRL CNTR/MD
IMMED.(SUPP DATA)
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:0F,-18C
Lower Limits:1.8 %
Upper Limits:10.0 %
Extinguishing Media:SML FIRES: USE DRY CHEMICAL, CO*2, WATER OR FOAM
EXTINGUISHER.
Fire Fighting Procedures:LRG FIRES: EVAUCATE AREA AND CALL FIRE
DEPARTMENT IMMEDIATELY. WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA, STOP LEAK IF IT CAN BE DONE
WITHOUT RISK. TAKE UP WITH SAND, EARTH, OR OTHER NON-COMBUSTIBLE
ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS AND
FLAMES; STORE IN COOL, DRY PLACE.
Other Precautions:CONTAINERS, EVEN EMPTIED WILL RETAIN RESIDUE AND
VAPORS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED CANNISTER RESPIRATOR IN
ABSENCE OF ADEQUATE VENTILATION.
Ventilation:GEN MECH: EXHST VENT CAPABLE OF MAINTAINING EMISSIONS AT
THE POINT OF USE BELOW PEL. LOC EXHST: OPEN DOORS (SUPP DATA)
Other Protective Equipment:EYE WASH AND SAFETY SHOWER SHOULD BE
AVAILABLE.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRST AID PROC: AVOID ALCOHOLIC BEVERAGES. NEVER GIVE ANYTHING BY MOUTH
TO AN UNCONSCIOUS PERSON. VENT: AND WINDOWS. IF USED IN ENCLOSED
AREA, USE EXHAUST FANS.
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:174F,79C
Vapor Pres:70 @ 20C
Vapor Density:2.5
Spec Gravity:0.807 +/- 0.01
Evaporation Rate & Reference:5.5-8.0 (BUTYL ACETATE=1)
Solubility in Water:28 PARTS
Appearance and Odor:CLEAR LIQUID. SHARP, FRAGRANT, MINT/ETHER ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS, OXIDIZING MATLS, ALKALIS, CHLORINATED INORGANICS (POTASSIUM,
CALCIUM & SODIUM HYPOCHLORITE), COPPER/COPPER ALLOYS
Stability Condition to Avoid:HEAT, SPARKS AND OPEN FLAME.
Hazardous Decomposition Products:CARBON MONOXIDE/CARBON
DIOXIDE/HYDROGEN CHLORIDE/SMOKE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDING TO LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:F47-0891-500, INK CARTRIDGE, W/O PRINT HEAD (SUPDAT)
CAGE:EO274
CAGE:EO274
============= Composition/Information on Ingredients =============
Ingred Name:NO INGREDIENT FOR THIS FORMULATION_INGREDIENT
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL:NO SPECIFIC HAZARDS ARE KNOWN TO
CANON UNDER USUAL CONDITION. INGEST:MAY BE HARMFUL IF SWALLOWED.
EYE/SKIN CONTACT:MAY CAUSE SLIGHT IRRITATION.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:IF PERSON BREATHES IN LARGE AMOUNTS, REMOVE TO FRESH
AIR. GET MEDICAL ATTENTION. INGEST:CALL MD. EYE:FLUSH W/PLENTY OF
WATER FOR AT LEAST 15 MINUTES. SKIN:WASH W/WATER & SOAP.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER, CO*2, DRY CHEMICALS.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:WIPE OFF W/PAPER OR WET CLOTH.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP OUT OF REACH OF CHILDREN. DO NOT
TAKE INTERNALLY.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN . NOT REQUIRED.
Ventilation:NOT REQUIRED.
Other Protective Equipment:NOT REQUIRED.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
MFR'S TRADE NAME/PART NO:FOR COLOR INK JET PRINTER BJ-A531A (COLOR)
(M3329G/A). SPEC GRAV:1.07-1.08 (H*2O=1).
================== Physical/Chemical Properties ==================
Spec Gravity:SUPP DATA
pH:8-10
Solubility in Water:MISCIBLE
Appearance and Odor:THREE COLORS (CYAN, MAGENTA, YELLOW) LIQUID; MILD
ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:AMMONIA.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL SHOULD BE SUBJECT TO FEDERAL, STATE &
LOCAL LAWS.
| 0 | eyes_protection_not_mandatory |
===================== Product Identification =====================
Product ID:EXTERIOR TOUGHCOAT FLAT WHITE LATEX PAINT,(
CAGE:0GB20
CAGE:0GB20
============= Composition/Information on Ingredients =============
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 20%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:1,2-PROPANEDIOL; (PROPYLENE GLYCOL)
CAS:57-55-6
RTECS #:TY2000000
Fraction by Wt: 5%
Ingred Name:ETHYLENE GLYCOL (SARA III)
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: 5%
OSHA PEL:50 PPM, C
ACGIH TLV:50 PPM,VAPOR, C
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:PROPIONIC ACID, 2-METHYL-, MONOESTER WITH
2,2,4-TRIMETHYL-1,3-PENTANEDIOL; (TEXANOL)
CAS:25265-77-4
RTECS #:UF6000000
Fraction by Wt: 5%
Ingred Name:HYDROTREATED LIGHT PETROLEUM DISTILLATE; (ALIPHATIC
PETROLEUM DISTILLATE)
CAS:64742-47-8
Fraction by Wt: 1%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
Ingred Name:VOLATILE ORGANIC COMPOUND: 1.16 GR/LTR: 139
RTECS #:9999999VO
Fraction by Wt: SEE ING
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL: VAPOR OR MIST CAN CAUSE
HEADACHE NAUSEA, AND IRRITATION OF THE NOSE, THROAT AND LUNGS.
CAUSES EYE IRRITATION. CAUSES SKIN IRRITATION.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE
======================= First Aid Measures =======================
First Aid:EYE:FLUSH W/WATER FOR AT LEAST 15 MIN WHILE HOLDING EYELIDS
OPEN. GET MED ATTN. SKIN:WASH W/SOAP & WATER. REMOVE CONTAM CLTHG &
SHOES; DO NOT REUSE UNTIL CLEANED. IF PERSISTENT IRRIT OCCURS, GET
MED A TTN. INHAL:REMOVE VICTIM TO FRESH AIR &PROVIDE OXYGEN IF
BRTHG IS DFCLT. GIVE ARTF RESP IF NOT BRTHG. GET MED ATTN.
INGEST:DO NOT INDUCE VOMIT. DILUTE BY GIVING WATER OR MILK TO DRINK
IF CONSCIOUS.
===================== Fire Fighting Measures =====================
Extinguishing Media:EXTINGUISHING MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:EVACUATE HAZ AREA OF UNPROT PERSONNEL. WEAR
NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE EQUIPMENT . COOL
FIRE-EXPOSED CONTAINERS WITH WATER.
Unusual Fire/Explosion Hazard:PRODUCT WILL NOT BURN BUT MAY SPATTER IF
TEMPERATURE EXCEEDS BOILING POINT.
================== Accidental Release Measures ==================
Spill Release Procedures:LARGE SPILL: EVACUATE THE HAZ AREA OF
UNPROTECTED PERSONNEL. WEAR APPROPRIATE NIOSH/MSHA APPROVED
RESPIRATOR AND PROTECTIVE CLOTHING. DIKE AND CONTAIN. TRANSFER TO
STROAGE/SALVAGE VESSELS. SOAK UP RES IDUE W/AN ABSORBENT SUCH AS
CLAY OR SAND.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT/SPARKS/OPEN FLAME.
KEEP CNTNRS TIGHTLY CLSD.STORE AWAY FROM STRONG OXIDIZING AGENTS IN
A COOL, DRY PLACE PLACE W/EXPLO-PROOF VENT.
Other Precautions:NONE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:WEAR PROTECTIVE CLOTHING AS REQUIRED TO
PREVENT SKIN CONTACT.
Work Hygienic Practices:WASH WITH SOAP AND WATER BEFORE EATING,
DRINKING, SMOKING OR USING TOILET FACILITIES. LAUNDER CONTAM BEFORE
REUSE.
Supplemental Safety and Health
MFR TRADE NAME/PART NO: 30097 FLAT BROWN.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:>369F,>187C
Vapor Pres:SEE ING 4
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN BUTYL ACETATE
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:60.3
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:CARBON MONOXIDE AND UNIDENTIFIED
ORGANIC COMPOUNDS MAY BE FORMED DURING COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF PRODUCT IN ACCORDANCE WITH LOCAL,
COUNTY, STATE, AND FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:LAURYL TRYTOSE BROTH WITH BROMCRESOL PURPLE, 26002
CAGE:4T252
CAGE:4T252
============= Composition/Information on Ingredients =============
Ingred Name:PROTEIN HYDROLYZATES; (TRYPTOSE)
CAS:9015-54-7
RTECS #:UK9595700
Fraction by Wt: <15%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:LACTOSE
CAS:63-42-3
RTECS #:OD9625000
Fraction by Wt: <5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SODIUM CHLORIDE
CAS:7647-14-5
RTECS #:VZ4725000
Fraction by Wt: <5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:OTHER COMPONENTS(EACH)
Fraction by Wt: <1%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PRACTICALLY NON-TOXIC. SPECIAL NOTE:
IN A LAB TEST, SINGLE SUBCUTANEOUS INJECTION OF SODIUM CHLORIDE
INTO PREGNANT MICE AT LEVEL OF 2500 MG/KG CAUSED FETAL DEAFNESS &
MALFORMATIONS. IN LAB TEST, MICE GIVEN A 2% SOLUTION IN PLACE OF
DRINKING WATER DURING PREGNANCY PRODUCED HYPERTENSIVE ADULT
OFFSPRING.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE REPORTED.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MINUTES. SKIN:
FLUSH W/PLENTY OF WATER. INGEST: GIVE LARGE QUANTITIES OF WATER.
CALL MD IMMED. INHAL: REMOVE TO FRESH AIR. SUPPORT BREATHING(GIVE
O*2/ARTF RESP).
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER, CARBON DIOXIDE OR DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:DILUTE WITH WATER. POUR DOWN THE DRAIN WITH
EXCESS WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE TIGHTLY CLOSED IN A COOL, DRY
PLACE.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN.
Ventilation:ADEQUATE VENTILATION.
Other Protective Equipment:EMERGENCY EYEWASH & DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Solubility in Water:SOLUBLE
Appearance and Odor:CLEAR DARK PURPLE LIQUID SOLUTION.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:BACTERIAL CONTAMINATION, HIGH
TEMPERATURES.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:B1636 N-T-BOC-B-ALA-TRP-MET-ASP-PHE AMIDE
CAGE:21076
CAGE:21076
============= Composition/Information on Ingredients =============
Ingred
Name:N-CARBOXY-BETA-ALANYL-L-TRYPTOPHYL-L-METHIONYL-L-ASPARTYLHENYL
-, N-TERT-BUTYL ESTER, L-
CAS:5534-95-2
RTECS #:AY2970000
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(RAT): >100 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY BE HARMFUL BY INHALATION,
INGESTION/SKIN ABSORPTION. BIOACTIVE PEPTIDE. STIMULATES THE
SECRETION OF GASTRIC ACID, PEPSIN & INTRINSIC FACTOR.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:NAUSEA, ABDOMINAL CRAMPS, FLUSHING OF THE SKIN,
HEADACHE, DROWSINESS, DIZZINESS, HYPOTENSION.
======================= First Aid Measures =======================
First Aid:INGESTION: WASH OUT MOUTH W/WATER IF CONSCIOUS. SKIN: FLUSH
W/COPIOUS AMOUNTS OF WATER FOR 15 MINS. INHALATION: REMOVE TO FRESH
AIR. EYES: FLUSH W/COPIOUS AMOUNTS OF WATER FOR 15 MINS. OBTAIN
MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:CO2, DRY CHEMICAL POWDER/APPROPRIATE FOAM.
Fire Fighting Procedures:WEAR SCBA & PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:EMITS TOXIC FUMES UNDER FIRE CONDITIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. SWEEP UP, PLACE IN
A BAG & HOLD FOR WASTE DISPOSAL. VENTILATE AREA & WASH SITE AFTER
MATERIAL PICKUP IS COMPLETE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:MECHANICAL EXHAUST REQUIRED.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING & SHOES.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:444.2-446F
Solubility in Water:COMPLETE
Appearance and Odor:SOLID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:COMBUSTION: CO, CO2, NITROGEN OXIDES,
SULFUR OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISSOLVE/MIX W/A COMBUSTIBLE SOLVENT & BURN IN A
CHEMICAL INCINERATOR EQUIPPED W/AN AFTERBURNER & SCRUBBER,
IAW/FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:6111, ALCAN ALUMINUM METAL 6XXX SERIES ALLO
CAGE:01371
CAGE:01371
============= Composition/Information on Ingredients =============
Ingred Name:ZINC (SARA III) (PEL/TLV AS ZINC OXIDE)
CAS:7440-66-6
RTECS #:ZG8600000
Fraction by Wt: 0.15%
OSHA PEL:10 MG TDUST;5 FUME
ACGIH TLV:10 MG TDUST;5 FUME
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ALUMINUM (SARA III)
CAS:7429-90-5
RTECS #:BD0330000
Fraction by Wt: >95.65%
OSHA PEL:15MG/M3 TDUST;5 FUME
ACGIH TLV:10MG/M3 DUST;5 FUME
Ingred Name:SUPP DATA:PRESENCE OF OXIDES OF COPPER, LEAD OR IRON. HOT
ALUMINUM DOES NOT EXHIBIT ANY WARNING COLOR CHANGES, (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9:THEREFORE, CAUTION NEEDS TO BE EXCERCISED IF THE
METAL COULD BE HOT.
RTECS #:9999999ZZ
Ingred Name:EFTS OF OVEREXP:& PHARYNX, & HEAVY CONC OF MANGANESE DUST
MAY AFFECT CENTRAL NERV SYS. MIG WELDING OR PLASMA ARC(ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11:CUTTING OF ALUMINUM ALLOYS CAN GENERATE OZONE,
NITRIC OXIDES, & UV RADIA. OZONE OVEREXP MAY RSLT IN MUC (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12:MEMBRANE IRRIT, AS WELL AS OTHER PULMONARY
DISCOMFORTS.
RTECS #:9999999ZZ
Ingred Name:VENT:VENTILATION PROVISIONS MAY BE REQUIRED. SEE NATIONAL
FIRE PROTECTION ASSOCIATION CODES NFPA 65 AND 651.
RTECS #:9999999ZZ
Ingred Name:SILICON
CAS:7440-21-3
RTECS #:VW0400000
Fraction by Wt: 0.7-1.1%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:IRON (PEL/TLV AS IRON OXIDE)
CAS:7439-89-6
RTECS #:NO4465500
Fraction by Wt: 0.4%
OSHA PEL:10 MG/M3 (FE)
ACGIH TLV:5 MG/M3(FE)
Ingred Name:COPPER
CAS:7440-50-8
RTECS #:GL5325000
Fraction by Wt: 0.5-0.9%
OSHA PEL:1 MG/M3DUST;0.1 FUME
ACGIH TLV:1 MG/M3DUST;0.2 FUME
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:MANGANESE (SARA III). PERCENTGE (WT):0.15-0.45.
CAS:7439-96-5
RTECS #:OO9275000
Fraction by Wt: SEE ING
OSHA PEL:(C) 5 MG/M3 DUST
ACGIH TLV:5 MG/M3 DUST 9293
Ingred Name:MAGNESIUM
CAS:7439-95-4
RTECS #:OM2100000
Fraction by Wt: 0.5-1.0%
Ingred Name:CHROMIUM (SARA III)
CAS:7440-47-3
RTECS #:GB4200000
Fraction by Wt: 0.1%
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ALUMINUM DUSTS ARE CONSIDERED NUISANCE
PARTICULATES, WHICH HAVE LITTLE ADVERSE EFFECT ON LUNGS & DO NOT
PRODUCE SIGNIF ORG DISEASE OR TOX EFTS WHEN EXPOS ARE KEPT UNDER
REASONABLE CNTRL. ALUMINUM FUME S GENERATED IN MELTING/WELDING
CONSIDERED TO BE LOW HLTH RISK. DUE TO LOW CONC OF OTHER LISTED
INGREDS (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:THEIR PRESENCE IS LESS LIKELY TO CAUSE
HLTH CONCERN. EYE CNTCT W/ALUMINUM DUST MAY CAUSE ABRASION. SILICON
DUSTS CONSIDERED NUISANCE PARTICULATES. HEAVY CONC OF FRESHLY
FORMED FUMES OF COPPER , MAGNESIUM, & ZINC CAN PRODUCE SYMPS OF
METAL FUME FEVER. HIGH CONC OF COPPER DUST MAY CAUSE IRRIT TO MUC
MEMB (ING 11)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:MOVE TO VENTILATED AREA. IF DISCOMFORT PERSISTS, GET
MD. EYE:FLUSH WITH WATER FOR AT LEAST 15 MINUTES. IF IRRITATION
PERSISTS. GET MD. SKIN:FLUSH WITH COPIOUS AMOUNTS OF WATER. CALL MD
. I NGEST:CALL MD IMMEDIATELY .
===================== Fire Fighting Measures =====================
Extinguishing Media:IN CASE OF ALUMINUM FIRE USE CLASS D DRY POWDER
EXTINGUISHER OR DRY SAND. DO NOT USE WATER/HALOGENATED EXTING
MEDIA.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . DO NOT USE WATER OR HALOGENATED
EXTINGUISHING MEDIA.
Unusual Fire/Explosion Hazard:MOLTEN ALUMINUM MAY EXPLODE UPON CONTACT
WITH WATER. FINELY DIVIDED ALUMINUM MAY EXPLODE WHEN MIXED
W/HALOGEN ACIDS, HALOGENATED SOLVS, OR AMMONIUM (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:NOT APPLICABLE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NOT APPLICABLE.
Other Precautions:HANDLING MOLTEN ALUMINUM PRESENTS A SPECIAL HAZARD.
FOR MORE INFORMATION ON MOLTEN ALUMINUM, REQUEST A COPY OF
"GUIDELINES FOR HANDLING MOLTEN ALUMINUM" FROM THE ALUMINUM ASSOC.,
818 CONNECTICUT AVE., N.W., WASHINGTON, D.C., 20006.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATORY PROTECTION
APPROPRIATE FOR CONCENTRATIONS ABOVE EXPOSURE LIMITS.
Ventilation:IF VENT IS TO BE USED TO CONVEY FINELY DIVIDED ALUMINUM
GENERATED BY GRINDING, SAWING, OR ETC., SPECIAL (ING 14)
Other Protective Equipment:MOLTEN METAL & HANDLING REQUIRES USE OF BOTH
SECONDARY & PRIMARY PERS PROT EQUIP, REFER TO ALUMINUM ASSOC
GUIDELINES.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EXPLO HAZ:NITRATE. FINELY DIVIDED ALUMINUM REACTS W/HALOGEN ACIDS,
WATER, & SODIUM HYDROXIDE TO PRODUCE HYDROGEN GAS. CNDTNS TO
AVOID:ALUMINUM CAN FORM EXPLO MIXTURES W/BROMATES, IODATES, &
AMMONIUM N ITRATE. ALUMINUM SCRAP MUST BE THORO DRIED PRIOR TO
REMELTING. FINELY DIVIDED ALUMINUM CAN THERMITE IN THE (ING 9)
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:>900F,>482C
Spec Gravity:2.5-2.9(H2O=1)
Appearance and Odor:GREY TO SILVERY METALLIC SOLID; NO ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALUMINUM CAN CREATE EXPLO MIXTURES OF HYDROGEN IN PRESENCE OF HALOGEN
ACIDS OR SODIUM HYDROXIDE. FINELY DIVIDED (SUPDAT)
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NOT APPLICABLE.
==================== Disposal Considerations ====================
Waste Disposal Methods:RECYCLE. FINELY DIVIDED ALUMINUM MAY BE REACTIVE
& ITS HAZARD CHARACTERISTICS SHOULD BE DETERMINED PRIOR TO
DISPOSAL. DISPOSER MUST COMPLY WITH FEDERAL, STATE OR LOCAL WASTE
DISPOSAL LAWS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:THIOKOL MC-236 BASE TYPE II
Kit Part:Y
Preparer's Name:DAVID B.WIENCKOWSKI,DABT
CAGE:KO006
CAGE:KO006
CAGE:0U317
============= Composition/Information on Ingredients =============
Ingred Name:CALCIUM CARBONATE
CAS:471-34-1
RTECS #:FF9335000
Fraction by Wt: 40.2%
Other REC Limits:NONE RECOMMENDED
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 2.5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9495
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 0.36%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:SEE TABLE Z-3
ACGIH TLV:0.1 MG/M3 RDUST;9495
Ingred Name:NON-HAZARDOUS INGREDIENTS
Fraction by Wt: 55%
Other REC Limits:NONE RECOMMENDED
Ingred Name:FORMALDEHYDE (SARA 302/313) (CERCLA)
CAS:50-00-0
RTECS #:LP8925000
Fraction by Wt: <0.1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:SEE 1910.1048
ACGIH TLV:C 0.3 PPM, A2; 9495
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:ETHYLENE OXIDE (SARA 302/313) (CERCLA)
CAS:75-21-8
RTECS #:KX2450000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1 PPM; SEE 1910.1047
ACGIH TLV:1 PPM, A2; 9495
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
===================== Hazards Identification =====================
Health Hazards Acute and Chronic:EYES:MAY CAUSE MECHANICAL
IRRITATION.SKIN:PROLONGED CONTACT MAY CAUSE IRRITATION.INGEST:MAY
CAUSE GI TRACT IRRITATION.INHAL:NO ADVERSE EFFECTS
EXPECTED.CHRONIC:MAY CAUSE ALLERGIC REACTION.EXPOSURE TO
CRYSTALLINE SILICA DUST MAY CAUSE SILICOSIS.
Explanation of Carcinogenicity:CRYSTALLINE
SILICA:NTP-AC,IARC-2A.ETHYLENE
OXIDE:NTP-AC,IARC-2A,EPA-B2.FORMALDEHYDE IS LOWER THAN REPORTABLE
AMOUNT.
Effects of Overexposure:INGEST:NAUSEA,VOMITING AND GASTROINTESTINAL
UPSET.SILICOSIS:COUGHING,WHEEZING,CHEST PAIN.
Medical Cond Aggravated by Exposure:UNLIKELY TO AGGRIVATE EXISTING
MEDICAL CONDITIONS UNDER NORMAL CONDITIONS OF USE.
======================= First Aid Measures =======================
First Aid:SKIN:REMOVE CONTAMINATED CLOTHING;WASH WITH SOAP AND
WATER.SEE DOCTOR IF IRRITATION DEVELOPS.EYES:FLUSH WITH WATER FOR
15 MINUTES.SEE DOCTOR IF IRRITATION DEVELOPS.INHAL:REMOVE TO FRESH
AIR.GIVE OXYGE N OR ARTIFICIAL RESPIRATION IF NEEDED.INGEST:GET
PROMPT QUALIFIED MEDICAL ATTENTION.INDUCE VOMITING WITH SYRUP OF
IPECAC,FOLLOWED BY 2 GLASSES WATER OR STICK FINGER DOWN THROAT.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:>200F,>93C
Extinguishing Media:USE AGENTS APPROVED FOR CLASS A HAZARD(HALOGENATED
AGENTS,FOAM,STEAM,WATER FOG).
Fire Fighting Procedures:USE A SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE EQUIPMENT.
Unusual Fire/Explosion Hazard:FIRE CONDITIONS MAY EVOLVE TOXIC FUMES.
================== Accidental Release Measures ==================
Spill Release Procedures:SHOVEL OR VACUUM;PLACE COLLECTED MATERIAL IN
AN APPROPRIATE CONTAINER FOR DISPOSAL;CLEAN SPILL AREA TO REMOVE
SLIPPERINESS.DO NOT POLLUTE SEWERS,STREAMS OR WATERWAYS.
Neutralizing Agent:NOT APPLICABLE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL,DRY,WELL-VENTILATED
PLACE.KEEP CONTAINER CLOSED WHEN NOT IN USE.
Other Precautions:THIS PRODUCT CONTAINS FORMALDEHYDE,WHICH MAY
ACCUMULATE IN THE HEADSPACE OF SEALED CONTAINERS;USE PROPER
RESPIRATORY PROTECTIVE EQUIPMENT.EMPTY CONTAINERS MAY CONTAIN
HAZARDOUS RESIDUE;DISPOSE OF PROP ERLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHERE ENVIRONMENTAL CONTROLS ARE LACKING OR IN
ENCLOSED SPACES USE A SELF-CONTAINED BREATHING APPARATUS.IF THE PEL
FOR FORMALDEHYDE(2PPM-STEL) IS EXCEEDED USE A NIOSH/MSHA APPROVED
RESPIRATOR FOR FORM ALDEHYDE.
Ventilation:LOCAL VENTILATION AT THE WORKSITE;MECHANICAL(GENERAL)
VENTILATION TO MAINTAIN TLV/PEL.
Other Protective Equipment:PROVIDE A LOCAL EYE WASH STATION AND SAFETY
SHOWER.
Work Hygienic Practices:USE GOOD MANUFACTURING AND HANDLING
PRACTICES.WASH AFTER HANDLING PRODUCT AND BEFORE EATING,DRINKING OR
SMOKING.
Supplemental Safety and Health
KEY1;N1.NOTE TO PHYSICIAN:TREATMENT SHOULD BE DIRECTED AT PREVENTING
ABSORPTION.
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:1.61
Viscosity:9000-14000P
Solubility in Water:INSOLUBLE
Appearance and Odor:NOT REPORTED.
Percent Volatiles by Volume:97
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON DIOXIDE,CARBON MONOXIDE,OXIDES
OF NITROGEN AND SULFUR,PHENOLICS,HYDROGEN SULFIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:RECYCLE,INCINERATE OR SURRENDER TO A WASTE
TREATMENT FACILITY IN ACCORDANCE WITH FEDERAL,STATE AND LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:KRYTOX 240 SERIES FLUORINATED GREASES
Preparer's Name:ROBERT V.DAUM
CAGE:18873
CAGE:18873
============= Composition/Information on Ingredients =============
Ingred Name:PERFLUOROALKYLETHER
CAS:60164-51-4
Fraction by Wt: 85.0%
Other REC Limits:NONE SPECIFIED
Ingred Name:TELOMERS OF TETRAFLUOROETHYLENE
CAS:79070-11-4
Fraction by Wt: 15.0%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL RAT LD50 >25,000 MG/KG
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PRODUCT MAY BE MILDLY IRRITATION;
OTHERWISE IS PRACTICALLY NON-TOXIC. DECOMPOSITION PRODUCTS (FORMED
ABOVE 500F/260C) MAY CAUSE PILMONARY EDEMA,OR POLYMER FUME FEVER.
Effects of Overexposure:CONTACT MAY PRODUSE MILD IRRITATION. INHALATION
OF THERMAL DECOMPOSITION:RESPIRATORY IRRITATION,POLYMER FUME
FEVER(FLU-LIKE SYMPTOMS),PULMONARY EDEMA.
Medical Cond Aggravated by Exposure:NONE
======================= First Aid Measures =======================
First Aid:EYES:FLUSH WITH WATER 15 MIN. SKIN:REMOVE CONTAMINATED
CLOTHING. WASH AREA WITH SOAP AND WATER. LAUNDER CLOTHING BEFORE
REUSE. INHALED:REMOVE FROM EXPOSURE. GIVE ARTIFICIAL RESPIRATION OR
OXYGEN IF NE EDED. INGESTED:DO NOT INDUCE VOMITING. GIVE WATER OR
MILK. (NOTHING BY MOUTH IF UNCONSCIOUS) GET IMMEDIATE MEDICAL CARE.
IF SYMPTOMS PERSIST OR ARE SEVERE,GET MEDICAL CARE.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:NONE
Extinguishing Media:NOT FLAMMABLE. USE MEDIA APPROPRIATE FOR
SURROUNDING FIRE,
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED
CONTAINERS WITH WATER SPRAY. CONTAIN RUNOFF.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS.(FLUORINE COMPOUNDS)
================== Accidental Release Measures ==================
Spill Release Procedures:WIPE UP WITH CLOTH OR PAPER.
Neutralizing Agent:NONE
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL,DRY,WELL VENTILATED
AREA. KEEP TIGHTLY CLOSED. DO NOT PERMIT PRODUCT TO CONTAMINATE
FOOD,DRINK,TOBACCO PRODUCTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE EXPECTED TO BE NECESSARY, USE NIOSH/MSHA
SUPPLIED AIR RESPIRATOR IF PRODUCTS OF THERMAL DECOMPOSITION ARE
PRESENT.
Ventilation:NORMAL ROOM VENTILATION.
Work Hygienic Practices:USE GOOD INDUSTRIAL HYGIENE PRACTICE. AVOID
UNNECESSARY CONTACT. DO NOT CONTAMINATE FOOD,DRINK OR TABACCO
PRODUCTS
Supplemental Safety and Health
MSDS NO.5660PP
================== Physical/Chemical Properties ==================
HCC:V6
Melt/Freeze Pt:M.P/F.P Text:608F/320C
Spec Gravity:1.89-1.93
pH:NEUTRL
Solubility in Water:NEGLIGIBLE
Appearance and Odor:SOLID,WHITE,WAXY GREASE,NO ODOR.
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
METAL OXIDES AT ELEVATED TEMPERATURES.
Stability Condition to Avoid:ELEVATED TEMPERATURES (>550F/288C).
Hazardous Decomposition Products:FLUORINE,FLUORINE COMPOUNDS
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE I/A/W FEDERAL,STATE,LOCAL,REGULATIONS.
DO NOT FLUSH TO SURFACE WATER OR DRAIN. MFR SUGGESTS RECOVERY OR
INCINERATION.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:FACSIMILE CURING LIQUID, P 902 0000
Preparer's Name:MA
CAGE:2R260
CAGE:2R260
============= Composition/Information on Ingredients =============
Ingred Name:VENT: "INDUSTRIAL VENT: A MANUAL OF RECOM PRACTICE"
PUBLISHED BY ACGIH. LOC EXHST VENT IS PREF SINCE IT PVNTS (ING 4)
RTECS #:9999999ZZ
Ingred Name:ING 3: CONTAM DISPERSION INTO WORK AREA CONTROLLING IT AT
ITS SOURCE.
RTECS #:9999999ZZ
Ingred Name:METHACRYLIC ACID, METHYL ESTER; (METHYL METHACRYLATE) (SARA
313) (CERCLA) LD50: (ORAL, RAT) 7990 MG/KG
CAS:80-62-6
RTECS #:OZ5075000
Fraction by Wt: >99%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:HYDROQUINONE (SARA 302/313) (CERCLA)
CAS:123-31-9
RTECS #:MX3500000
Fraction by Wt: <0.01%
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENT 1
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:FOR METHYL METHACRYLATE MONOMER:
LIQUID OR HIGH VAPOR CONCENTRATION CAN IRRITATE EYES, RESPIRATORY
SYS & CAUSE SKIN RASHES. PRLNG EXPOS CAN LEAD TO HEADACHES, NAUSEA,
STAGGERING GAIT, CONFUSION, DROWS INESS & UNCON. RPTD & PRLNG
OVEREXP MAYCAUSE PERMANENT BRAIN & NERVOUS SYS DMG, ALLERGIC SKIN
RASHES, (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: EYE CORROSION & PERMANENT INJURY AS
WELL AS CHANGES IN LIVER & KIDNEY FUNCTION/DAMAGE. FOR
HYDROQUINONE: MAY IRRITATE EYES, CAUSE CONTACT DERMATITIS & CASES
OF POISONING, HOWEVER, 300-500 MG /DAY/5 MOS CAUSED NO ABNORMS IN
STUDIESOF BLOOD & URINE. TARGET ORGANS: FOR HYDROQUINONE: KIDNEYS &
EYES.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. IF BREATHING HAS STOPPED GIVE
OXYGEN. GET MED HELP IF DISCOMFORT PERSISTS. EYES: FLUSH W/WATER
FOR AT LEAST 15 MIN, INCLUDING UNDER EYELIDS. CONTACT MD. SKIN:
WASH THORO W/ SOAP & WATER. REMOVE CONTAMINATED CLOTHING. WASH
CLOTHING THOROUGHLY BEFORE REUSE. INGEST: DO NOT INDUCE VOMITING.
DILUTE W/2 GLASSES OF WATER. NEVER GIVE ANYTHING TO AN UNCON
PERSON. CONTACT MD.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:50.0F,10.0C
Lower Limits:2.12%
Upper Limits:12.5%
Extinguishing Media:CHEMICAL FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . USE WATER SPRAY TO COOL CONTAINERS.
EXPLOSION HAZARD - FIGHT FIRE FROM PROTECTED LOCATION.
Unusual Fire/Explosion Hazard:WHEN HEATED ABOVE FL PT, FLAMM VAPS ARE
EMITTED CAN MIX W/AIR CAN BURN OR BE EXPLO. VAPS ARE HVR/AIR & MAY
TRAVEL TO SOURCE OF IGNIT & FLASH BACK. HEAT (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE AREA. ELIM SOURCES OF IGNIT. USE
NIOSH/MSHA APPRVD SCBA & PROT CLTHG. DIKE & ABSORB W/INERT MATL.
TRANSFER TO PROPER CNTNRS FOR DISP, USE NON-SPK TOOLS. CONTAMD
MONOMER MAY BE UNSTABLE, ADD I NHIBITOR TO PVNT POLYM. KEEP SPILLS
& (SUPDAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:OBSERVE PRECAUTIONS FOUND ON THE
LABEL. STORE IN COOL, DRY PLACE AWAY FROM HEAT, SPARKS, FLAME AND
DIRECT SUNLIGHT. CLOSE CONTAINER AFTER EACH USE.
Other Precautions:GROUND ALL METAL CONTAINERS WHEN TRANSFERRING. USE
EXPLOSION-PROOF EQUIPMENT. CHECK INHIBITOR LEVELS EVERY THREE
MONTHS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:DO NOT BREATHE MISTS OR VAPORS. USE NIOSH/MSHA
APPROVED SELF-CONTAINED BREATHING APPARATUS WHEN NEEDED OR WHEN
LEVEL EXCEEDS 100 PPM.
Ventilation:USE LOC EXPLOS-PROOF VENT W/MINIMUM CAPTURE VELOCITY OF 100
FT/MIN (30 M/MIN) AT PT OF MONOMER RELS. REFER TO (ING 3)
Other Protective Equipment:EYEWASH, SFTY SHOWER & IMPERVIOUS CLTHG.
PROT CREAMS SHOULD NOT BE USED FOR PROT BUT MAY BE USED FOR EASE OF
CLEAN UP.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING AND BEFORE
EATING OR SMOKING.
Supplemental Safety and Health
EXPLO HAZ: CAN CAUSE POLYM W/RAPID RELS OF ENERGY WHICH MAY RUPTURE
CNTNR EXPLOSIVELY. (SPONT POLYM MAY OCCUR ON PRLNG STORAGE). SPILL
PROC: CLEANING RUNOFFS OUT OF SEWERS & OPEN BODIES OF WATER. SPIL
LS ON POROUS SURFS CAN CONTAM GROUNDWATER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:214F,101C
Vapor Pres:29 @ 20C
Vapor Density:3.5 @ 60F
Spec Gravity:0.94 (H*2O=1)
Evaporation Rate & Reference:3.0 (BUAC=1)
Solubility in Water:MOD 1.6 G/100 G @20C
Appearance and Odor:CLEAR, PALE LIQUID; AN ACRID FRUITY ODOR.
Percent Volatiles by Volume:99+ WT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
REDUCING AGENTS, OXIDIZING AGENTS & UV LIGHT. MATERIAL HAS STRONG
SOLVENT PROPERTIES & CAN SOFTEN PAINT & RUBBER.
Stability Condition to Avoid:HEAT ABOVE 70F AND SOURCES OF IGNTION,
AGING AND CONTAMINATION.
Hazardous Decomposition Products:OXIDES OF CARBON WHEN BURNED.
Conditions to Avoid Polymerization:TEMPERATURES ABOVE 70F, OXIDIZING OR
REDUCING AGENTS, PEROXIDES, ACIDS, ALKALIES AND AMINES.
==================== Disposal Considerations ====================
Waste Disposal Methods:WHEN DISCARDED IT IS LISTED AS HAZARDOUS WASTE
BY EPA UNDER RCRA U-164 WITH REPORTABLE QUANTITY OF 1000 POUNDS (40
CFR PART 302). INCINERATE LIQUID & DIKING MATERIAL AFTER ADDITION
OF EXCESS INHIBITOR , I/A/W FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:SULPHURIC ACID 93-100%, 899190
CAGE:SULCX
CAGE:SULCX
============= Composition/Information on Ingredients =============
Ingred Name:SULFURIC ACID (SARA 302/313) (CERCLA). LD50:(ORAL,RAT) 2140
MG/KG.
CAS:7664-93-9
RTECS #:WS5600000
Fraction by Wt: 93-100%
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3;3 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SUPDAT:AMINES, CARBONATES & OTHER ALKALINE MATLS. RXNS CAN
GENERATE GREAT DEAL OF HEAT AS DOES DILUTION OF ACID W/WATER.
RTECS #:9999999ZZ
Ingred Name:EFTS OF OVEREXP:MAY CAUSE NAUS, VOMIT & DIARR. MAY CAUSE
DELAYED GASTRIC/ESOPHAGEAL PERFORATION. SWALLOWING MAY (ING 4)
RTECS #:9999999ZZ
Ingred Name:ING 3:BE FATAL. CHRONIC:RPTD EXPOS MAY CAUSE CHRONIC
BRONCH, PULM EDEMA & EROSION/DISCOLORATION OF TEETH. RPTD (ING 5)
RTECS #:9999999ZZ
Ingred Name:ING 4:SKIN CONT W/DILUTE SOLNS MAY CAUSE DERM. SENSITIZING
CAPABILITY OF MATL:RPTD EXPOS TO SULPHURIC ACID MIST (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5:MAY INCR TOLERANCE OF IRRIT EFTS. SENSIT CAN DEVEL
AFTER BRIEF/PRLNG EXPOS, SUBSEQUENT EXPOS CAN RSLT IN (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6:ASTHMATIC ATTACKS.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC:EYES:FLUSH W/LG AMTS OF RUNNING WATER FOR AT
LST 15 MINS. HOLD LIDS APART TO ENSURE RINSING OF (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8:ENTIRE SURF OF EYE & LIDS W/WATER. GET IMMED MED
ATTN. MOVING VICTIM FROM WATER ACCESS FOR TRANSPORT TO (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9:MED AID SHOULD BE DONE ONLY ON ADVICE OF QUALIFIED
MED PERS. INGEST:GIVE WATER, DO NOT INDUCE VOMIT, CALL (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10:MD. IF VOMIT OCCURS KEEP HEAD BELOW HIPS TO PVNT
ASPIR OF LIQ INTO LUNGS. IF VOMIT OCCURS, GIVE FLUIDS (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11:AGAIN. CALL MD/POIS CTL CTR IMMED. NOTES TO
MD:APPLICATION OF ICE TO SKIN BURNS WILL REDUCE SCARRING.
RTECS #:9999999ZZ
Ingred Name:SPILL PROC:SODIUM BICARBONATE. FLUSH W/WATER I/A/W APPLIC
REGS. PUMP SPILLS MATL INTO MARKED CNTNRS FOR (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13:RECLAMATION/DISP. FOLLOW ALL APPLIC FIRE & EXPLO
PRECS DURING SPILL RESPONSE PROCEDURE.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENT 1.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:EXPOS TO VAPS MAY CAUSE PULM
IRRIT & INFLAMM, COUGH, PULM EDEMA & EYE IRRIT. SEV CHEM BURNS TO
EYES & SKIN. SEVERITY OF BURN IS GENRLY DETERM AT CONC OF SOLN &
DURATION OF EXPOS. SKIN CONT:CONT OF UNDILUTED PROD W/SKIN OR EYES
QUICKLY CAUSES SEV IRRIT & PAIN & MAY CAUSE BURNS, NECROSIS & PERM
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:SULFURIC ACID:IARC MONOGRAPHS, VOL 54,
PG 41, 1992:GROUP 1. ANIMAL:PULMONARY IRRITANT.
Effects of Overexposure:HLTH HAZ:INJURY. FOR DILUTE SOLNS:PRLNG/RPTD
CONT MAY CAUSE DRYING, CRACKING/IRRIT. EYE CONT:CONT OF LIQ WILL
CAUSE SEV BURNS. MAY RSLT IN PERM IMPAIRMENT OF VISION, EVEN
BLINDNESS. INHAL:MISTS & VAPS MAY CAUSE SEV IRRIT TO RESP TRACT.
INGEST:CAN CAUSE SEV BURNING & PAIN IN LIPS, MOUTH, TONGUE, THROAT
& STOM. (ING 3)
Medical Cond Aggravated by Exposure:MAY AGGRAVATE EXISTING DERMATITIS,
ASTHMA & INFLAMMATORY OR FIBROTIC PULMONARY DISEASE.
======================= First Aid Measures =======================
First Aid:INHAL:YOU MAY HAVE 10 SECS/LESS TO AVOID SERIOUS PERM INJURY.
REMOVE TO FRESH AIR. IF BRTHG HAS STOPPED, ADMIN ARTF RESP & SEEK
MED ATTN. SKIN:REMOVE CONTAM CLTHG & RINSE SKIN W/WATER FOR 15
MINS. GET IMMED MED ATTN. MOVING VICTIM FROM WATER ACCESS FOR
TRANSPORT TO MED AID SHOULD BE DONE ONLY ON ADVICE OF QUALIFIED MED
PERS. WASH CONTAM CLTHG THORO BEFORE RE-USE. DISCARD CONTAM SHOES.
(ING 8)
===================== Fire Fighting Measures =====================
Extinguishing Media:SUITABLE FOR SURROUNDING FIRE. CARBON DIOXIDE, DRY
CHEMICAL, FOAM.
Fire Fighting Procedures:USE NIOSH APPRVD SCBA & FULL PROT EQUIP . USE
WATER ON COMBUST BURNING IN VICIN OF THIS MATL BUT USE CARE AS
WATER APPLIED DIRECTLY TO ACID CAUSES(SUPDAT)
Unusual Fire/Explosion Hazard:EVOLUTION OF EXPLO HYDROGEN GAS ON CONT
W/MOST METALS. TOXIC GASES (SULPHURIC ACID FUMES, SULFUR DIOXIDE &
CARBON MONOXIDE) MAY BE RELS DUE TO THERMAL DECOMP.
================== Accidental Release Measures ==================
Spill Release Procedures:NOTIFY FIRE & ENVIRON AUTHS. UTILIZE FULL PROT
CLTHG, INCL BOOTS & NIOSH APPRVD SCBA. CNTN SPILL IN ORDER TO PVNT
CONTAM OF SEWAGE SYS/WATERWAY. REMOVE ALL SOURCES OF IGNIT. IF POSS
NEUT ON DRY BASIS W/SUITABLE ALKALI SUCH AS LIME, SODA ASH/ (ING
13)
Neutralizing Agent:ALKALI SUCH AS LIME, SODA ASH OR SODIUM BICARBONATE.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS & OPEN
FLAMES. PROTECT CNTNR FROM PHYSICAL DMG. KEEP CNTNR CLSD WHEN NOT
IN USE. STORE AWAY FROM INCOMPATIBLE MATLS.
Other Precautions:AVOID ALL SKIN CONT. AVOID GETTING IN EYES. USE
W/ADEQ VENT. WHEN DILUTING, SLOWLY ADD ACID TO WATER WHILE
STIRRING, NEVER ADD WATER TO ACID. EMPTY CNTNRS RETAIN VAP & PROD
RESIDUE. EMPTY CNTNRS ARE H AZ, MAY CONTAIN FLAMM/EXPLO LIQ
(SUPDAT)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED RESPIRATOR.
Ventilation:VENTILATE ADEQUATELY.
Other Protective Equipment:ANSI APPROVED EYE WASH FOUNTAIN & DELUGE
SHOWER . ALWAYS WEAR IMPERVIOUS PROTECTIVE CLOTHING. BOOTS.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. MAINTAIN A GOOD
PERSONAL HYGIENE.
Supplemental Safety and Health
BP:93.19%-549F,287C; 96%-606F,319C; 98%-633F,334C; 100%-525F;274C. SPEC
GRAV(H*2O=1):93.19%-1.8354; 96%-1.8427; 98%-1.8437; 100%-1.8391.
FIRE FIGHT PROC:SPATTERING OF ACID. CNDTNS (STAB):AVOID EXCESSI VE
HEAT, SPKS & OPEN FLAME. OTHER PREC:RESIDUE/VAP. EYE PROT:FULL LGTH
FSHLD . MATLS TO AVOID:HYDROXIDES, (ING 2)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:SUPP DATA
Vapor Pres:0.0018
Vapor Density:3.4
Spec Gravity:SUPP DATA
pH:<1
Solubility in Water:MISCIBLE
Appearance and Odor:LIQUID; NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
HIGHLY REACTIVE W/MANY MATLS INCL WATER, METALS, METAL OXIDES,
CARBIDES, CHLORATES, PICRATES, NITRATES, (SUPP DATA)
Stability Condition to Avoid:CONCENTRATED ACID IS STRONG OXIDIZING
AGENT. MAY CAUSE IGNIT OF COMBUST MATL ON CONT W/GENERATION OF TOX
FUMES. (SUPDAT)
Hazardous Decomposition Products:SULPHURIC ACID DECOMPOSITION MAY
RESULT IN RELEASE OF TOX GASES (SULPHURIC ACID FUMES, SULPHUR
DIOXIDE, CARBON MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS . DISPOSAL I/A/W MUNICIPAL, PROVINCIAL & FEDERAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:PREMIUM UNLEADED GASOLINE
CAGE:4N717
CAGE:4N717
============= Composition/Information on Ingredients =============
Ingred Name:ING 17:OPEN SPILLS MAY EMIT FLAMM VAPS. APPROACH FROM
UPWIND IF POSS. AVOID BRTHG EMITTED VAPS. WEAR NIOSH/MSHA (ING 19)
RTECS #:9999999ZZ
Ingred Name:ING 18:APPRVD SELF CNTND POSITIVE PRESS BRTHG APPARATUS, IF
REQD, TO PVNT INHAL OF VAPS.
RTECS #:9999999ZZ
Ingred Name:WASTE DISP METH:OF VOLATILE, FLAMMABLE, VAPORS.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC: IGNIT. USE ONLY AS A MOTOR FUEL. HNDLE,
TRANSPORT & STORE I/A/W APPLIC LAWS & REGS. ELEC EQUIP (ING 22)
RTECS #:9999999ZZ
Ingred Name:ING 21:SHOULD BE APPRVD FOR CLASSIFIED AREA. REMOVE SOILED
CLTHG & LAUNDER BEFORE-REUSE. DISCARD OIL SOAKED (ING 23)
RTECS #:9999999ZZ
Ingred Name:ING 22:SHOES. WEAR FULL LNGTH CLTHG, & LAUNDER ON A REGULAR
& FREQ BASIS. VENT MUST BE SUFFICIENT TO PVNT (ING 24)
RTECS #:9999999ZZ
Ingred Name:ING 23:ACCUMULATION OF TOX/FLAMM CONC OF VAPOR IN AIR.
RTECS #:9999999ZZ
Ingred Name:HYGIENE PRACT: UPWIND OF VAPOR OR MIST RELEASE, SPILL OR
LEAK.
RTECS #:9999999ZZ
Ingred Name:ETHER, TERT-BUTYL METHYL; (METHYL TERT-BUTYL ETHER &/OR
TERT-AMYL METHYL ETHER, CAS # 994-05-8)
CAS:1634-04-4
RTECS #:KN5250000
Fraction by Wt: <15%
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:TOLUENE
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 15-<30%
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:XYLENE (MIXED ISOMERS)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 10-<15%
OSHA PEL:100 PPM;150 PPM STEL
ACGIH TLV:100 PPM;150 PPM STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:BENZENE
CAS:71-43-2
RTECS #:CY1400000
Fraction by Wt: 0.1-<5%
OSHA PEL:10 PPM
ACGIH TLV:10 PPM
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:BENZENE, ETHYL-; (ETHYL BENZENE)
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: <3%
OSHA PEL:100 PPM;125 STEL
ACGIH TLV:100 PPM;125 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:BENZENE, 1,2,4-TRIMETHYL-; (1,2,4-TRIMETHYLBENZENE)
CAS:95-63-6
RTECS #:DC3325000
Fraction by Wt: <6%
Ingred Name:SUPP DATA: IGNIT. VAPS CAN READILY FORM EXPLOS MIXT IN AIR.
HVR/AIR VAPS CAN FLOW ALONG SURF TO DIST SOURCES (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8:IGNIT & FLASH BACK. FLOWING GASOLINE CAN BE IGNITED
BY SELF-GENERATED STATIC ELEC. RUNOFF TO SEWERS (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9: MAY CREATE FIRE &/OR EXPLOSION HAZARD.
RTECS #:9999999ZZ
Ingred Name:EFTS OF OVEREXP:DISEASE, INCL LEUKEMIA, AFTER RPTD & PRLNGD
EXPOS @ HIGH CONC.INHAL TO 100 PPM MAY CAUSE SLIGHT (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11:DROW & HDCH. 100-200 PPM MAY CAUSE FATG, NAUS, ITCH
& WILL FATG OLFACTORY SENSES.IMMED DANGER TO HLTH/ (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12:LIFE IS REPRESENTED BY 2,000 PPM. INGEST & INHAL OF
LIQ &/OR EXCESS VAPS CAN HAVE AN ANESTH EFT, CAUSE (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13:VERTIGO, BLURRED VISION, VOMIT & CYANOSIS. OVEREXP
MAY CAUSE CNS DEPRESS. NOTE: TOLUENE CAS# 108-88-3 (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14:APPEARS ON NAVY LIST OF OCCUP REPROD HAZ. SEEK
CONSULTATION FROM APPROP HLTH PROFESSIONALS CONCERNING (ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15:LATEST HAZ LIST INFO & SAFE HANDLING AND EXPOSURE
RECOMMENDATION .
RTECS #:9999999ZZ
Ingred Name:SPILL PROC: ANIMAL/AQUATIC LIFE. CAUTION-EVAC ALL
NON-ESSENTIAL PERS. SPILLED MATL MAY CAUSE SLIPPERY CNDTNS. (ING
18)
RTECS #:9999999ZZ
Ingred Name:GASOLINE CONTAINING INGS 2-7
CAS:8006-61-9
RTECS #:LX3300000
Fraction by Wt: 100%
OSHA PEL:300 PPM;500 STEL
ACGIH TLV:300 PPM;500 STEL
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE/CHRONIC: HARMFUL/FATAL IF
SWALLOWED/ASPIRATED. LONG TERM EXPOS TO VAPS HAS CAUSED CANCER IN
SOME LAB ANIMALS. INGEST MAY CAUSE GI DISTURB. ASPIR INTO LUNGS MAY
CAUSE PNEUM. PRLNGD CONT W/SKIN MA Y RSLT IN DEFAT/RED, ITCH,
INFLAMM, CRACK & POSS SECONDARY INFECTION. HAS A LOW ORDER OF ACUTE
ORAL TOX(EFTS OF OVEREXP)
Explanation of Carcinogenicity:BENZENE: OSHA REG 29 CFR 1910.1028, REV
JUL 92; KNOWN CARCINOGEN (NTP) NTP 6TH ANN RPT, 1991; IARC
2B,VOL45,P159,1989.
Effects of Overexposure:HLTH HAZ:IF INGESTED, BUT MIN AMTS ASPIRATED
DURING SUCH INGEST MAY CAUSE DEATH. HIGH PRESS SKIN INJECTIONS ARE
SERIOUS MED EMER! RPTD/PRLNGD EXPOS TO VAPS CNTNG HIGH CONC OF
BENZENE MAY CAUSE ANEMIA & OTHER BLOOD DISEASES, INCL LEUKEMIA.
BENZENE IS RECOGNIZED AS HAVING POTNTL TO INDUCE ANEMIA & OTHER
BLOOD (ING 11)
Medical Cond Aggravated by Exposure:OPEN WOUNDS, SKIN DISORDERS,
CHRONIC RESPIRATORY DISEASE OR PRE-EXISTING CENTRAL NERVOUS SYSTEM
DISEASE.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR, PROVIDE OXYGEN THERAPY &/OR
RESUSCITATION AS INDICATED. SKIN: REMOVE CONTAMINATED CLOTHING &
FLUSH WITH SOAP AND WATER. EYE: FLUSH WITH WATER FOR AT LEAST 15
MINUTES. INGES T: RINSE MOUTH W/WATER. KEEP CALM AND WARM. DO NOT
INDUCE VOMIT! ASPIRATION OF MATERIAL INTO LUNGS MAY CAUSE CHEMICAL
PNEUMONIA. CALL PHYSICIAN IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:-40F,-40C
Lower Limits:1.4%
Upper Limits:7.4%
Extinguishing Media:ANY APPRVD EXTING AGENT FOR CLASS B FIRES, DRY
CHEM, FOAM, CARBON DIOXIDE/HALON. WATER IS NOT ORD EFTIVE. (SUPP
DATA)
Fire Fighting Procedures:NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP.
AVOID INHAL OF VAPS. WATER SHOULD BE USED TO KEEP EXPOS CONTRS
COOL. APPROACH FROM UPWIND IF POSSIBLE.
Unusual Fire/Explosion Hazard:CLASS 1A FLAMM LIQ. KEEP AWAY FROM HEAT,
SOURCES OF IGNIT & OXIDIZERS. BURNING MAY CAUSE EMISSION OF TOX
PROD OF COMBUST. EMPTY PROD CNTRS/VESSELS (SUPP DATA)
================== Accidental Release Measures ==================
Spill Release Procedures:CNTN ALL SPILLS. ABSORB ALL FREE LIQ. REMOVE
ALL IGNIT SOURCES & SAFELY STOP FLOW OF SPILL. PVNT FROM ENTERING
ALL BODIES OF WATER. COMPLY W/ALL APPLIC LAWS & REGS. ABSORB MATL,
PADS, SAND/EARTH MAY B E USED. CONTAM WATER/SOIL MAY BE HAZ TO(ING
17)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS & OPEN
FLAME. AVOID BRTHG VAP/MIST. AVOID SKIN/EYE CONTACT. KEEP
CONTAINERS CLOSED & PLAINLY LABELED.
Other Precautions:TRANSFER LINES MUST BE BONDED & GROUNDED TO PVNT
POTNTL ACCUMULATION OF STATIC ELEC. NO SMOKING IN AREAS OF
HNDLG/STOR. STOR SHOULD BE IN TIGHTLY CLSD CONTRS IN COOL, DRY,
ISOLATED & WELL VENTD AREA A WAY FROM POTNTL SOURCE OF (ING 21)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPRVD SELF CNTND, POSITIVE PRESSURE,
BREATHING APPARATUS IN CONFINED SPACES/WHEN EXPOSED TO HEAVY MIST.
Ventilation:LOCAL EXHAUST: GENERALLY NOT REQD. MECH(GEN): EXPLOSION
PROOF (APPROVED FOR CLASSIFIED AREA). SPECIAL: NONE REQUIRED.
Other Protective Equipment:IMPERVIOUS CLOTHING AS REQUIRED TO PREVENT
SKIN CONTACT. EYE WASH/BATH READILY AVAILABLE WHERE EYE CONTACT IS
POSSIBLE.
Work Hygienic Practices:WASH SKIN THORO W/SOAP & WATER BEFORE EATING,
DRINK/SMOKING. VENT MAY BE USED TO CTL/REDUCE AIRBORNE CONC.
STAND(ING 25)
Supplemental Safety and Health
VP: 275-475@68F (VARIES SEASONALLY). APPEAR/ODOR: (CLEAR RED, BRONZE &
YELLOW ARE TYPICAL). EXTING MEDIA: HOWEVER, WATER FOG MAY BE USED
BY EXPER FIRE FIGHTERS FOR INTENSITY CTL, & TO COOL EXPOSED ARE AS.
EXPLO HAZ: MAY CNTN EXPLOS VAPS. DONOT PRESSURIZE, CUT, HEAT,
WELD/EXPOSE SUCH CONTRS/VESSELS TO SOURCE OF (ING 8)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>85F,>29.4C
Vapor Pres:SUPP DATA
Vapor Density:3-4
Spec Gravity:0.76(H*2O=1)
Evaporation Rate & Reference:10-11(BUTYL ACETATE=1)
Solubility in Water:SLIGHT
Appearance and Odor:CLEAR LIQ W/CHARACT AROMATIC ODOR.MAY BE DYED FOR
IDENTIFICATION (SUPP DATA)
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS. COMBINATION OF NITRIC AND SULFURIC ACIDS.
Stability Condition to Avoid:AVOID HANDLING OR STORING NEAR HEAT,
SPARKS/OPEN FLAME.
Hazardous Decomposition Products:CONTACT WITH NITRIC AND SULFURIC ACIDS
WILL FORM NITROCRESOLS THAT CAN DECOMPOSE VIOLENTLY.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF PROD & CONTAMD MATL AS EPA "IGNITABLE
HAZ WASTE". USE ONLY APPRVD TRTMT TRANSPORTERS & DISP SITE IN
COMPLIANCE W/ALL APPLIC FED, ST & LOC REGS . MAINTAIN SURVEILLANCE
OF ABSORBED MATL UNTIL FINAL DISP TO OBSERVE FOR EMISSION (ING 20)
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:100 7509 COLOR DEVELOPER REPLENISHER, PROCESS E- 6AR, PART B
Kit Part:Y
CAGE:19139
CAGE:19139
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 90-95%
Other REC Limits:NONE RECOMMENDED
Ingred Name:4-(N-ETHYL-N-2-METHANESULFONYLAMINOETHYL)-2-
METHYLPHENYLENEDIAMINE
CAS:25646-71-3
RTECS #:PB0431000
Fraction by Wt: 5-10%
Other REC Limits:1MG/M3 TWA
Ingred Name:SODIUM BISULFITE (SASA III)
CAS:7631-90-5
RTECS #:VZ2000000
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3; 9394
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT): 400 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:VAPOR IRRITATING. LIBERATES SO2 GAS
WHICH CAN IRRITATE RESPIRATORY TRACT. CAUSES EYE IRRITATION. CAUSES
SKIN IRRITATION. MAY CAUSE ALLERGIC SKIN REACTION. MAY CAUSE
IRRITATION OF THE GASTROINTESTINALTRACT.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:EYE IRRITATION, SKIN IRRITATION, GI TRACT
IRRITATION, ALLERGIC SKIN REACTION.
Medical Cond Aggravated by Exposure:SIME ASTHMATICS OR HYPERSENSITIVE
INDIVIDUALS MAY EXPERIENCE DIFFICULT BREATHING.
======================= First Aid Measures =======================
First Aid:INHALATION: IF SYMPTOMATIC, MOVE TO FRESH AIR. GET MEDICAL
ATTENTION IF SYMPTOMS PERSIST. EYES: WASH OUT IMMEDIATELY WITH
WATER. GET MEDICAL ATTENTION IF SYMPTOMS OCCUR. SKIN: IMMEDIATELY
REMOVE CONTA MINATED CLOTHING AND WASH WITH SOAP ANDPLENTY OF
WATER. GET MEDICAL ATTENTION IF SYMPTOMS OCCUR. INGESTION: DRINK
1-2 GLASSES OF WATER. SEEK MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:NONFLAMMABLE. USE MEDIA SUITABLE FOR SURROUNDING
FIRE.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY CAUSE
PRODUCTION OF HAZARDOUS DECOMPOSITION PRODUCTS.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH TO SEWER WITH LARGE AMOUNTS OF WATER IF
ALLOWABLE. OTHERWISE, ABSORB SPILL WITH VERMICULITE OR OTHER INERT
MATERIAL, THEN PLACE IN A CONTAINER FOR CHEMICAL WASTE. CLEAN
SURFACE THOROUGHLY TO REM OVE RESIDUAL CONTAMINATION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT GET IN EYES AND AVOID CONTACT
WITH SKIN AND CLOTHING. USE WITH ADEQUATE VENTILATION. WASH
THOROUGHLY AFTER HANDLING. KEEP CONTAINER CLOSED.
Other Precautions:LAUNDER CONTAMINATED CLOTHING BEFORE REUSE. DESTROY
OR THOROUGHLY CLEAN CONTAMINATED SHOES. KEEP AWAY FROM INCOMPATIBLE
SUBSTANCES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF ENGINEERING CONTROLS DO NOT MAINTAIN AIRBORNE
CONCENTRATIONS BELOW RECOMMENDED EXPOSURE LIMITS, AN APPROVED
RESPIRATOR MUST BE WORN. RESPIRATOR TYPE: ACID GAS.
Ventilation:GOOD GENERAL VENTILATION (TYPICALLY 10 AIR CHANGES PER
HOUR) SHOULD BE USED. RATES SHOULD MATCH CONDITIONS.
Other Protective Equipment:WASHING FACILITIES, AN EMERGENCY EYE WASH
STATION AND SHOWER SHOULD BE AVAILABLE.
Work Hygienic Practices:WASH WITH SOAP AND WATER AFTER HANDLING PRODUCT
AND BEFORE EATING DRINKING OR SMOKING.
Supplemental Safety and Health
PART A OF THIS KIT IS NSN:6750-01-034-1017.PART B OF THIS KIT IS
NSN:6750-01-033-5154.
================== Physical/Chemical Properties ==================
HCC:C1
Boiling Pt:B.P. Text:>212F,>100C
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Vapor Pres:18
Vapor Density:0.6
Spec Gravity:1.02
pH:1.4
Evaporation Rate & Reference:NOT GIVEN
Solubility in Water:COMPLETE
Appearance and Odor:LIGHT AMBER LIQUID, SULFUR DIOXIDE ODOR
Percent Volatiles by Volume:90-95%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
BASES
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
SULFUR DIOXIDE, NITROGEN OXIDES
==================== Disposal Considerations ====================
Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT, RESIDUE, DISPOSAL CONTAINER OR
LINER IN ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:123 0895 DEVELOPER D-76, CONCENTRATE
CAGE:19139
CAGE:19139
CAGE:5K871
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM SULFITE
CAS:7757-83-7
RTECS #:WE2150000
Fraction by Wt: 85 - 90%
Other REC Limits:NONE RECOMMENDED
Ingred Name:HYDROQUINONE (SARA 302/313) (CERCLA)
CAS:123-31-9
RTECS #:MX3500000
Fraction by Wt: 4%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3; 9596
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SODIUM BORATE (TETRABORATE), PENTAHYDRATE
CAS:12179-04-3
RTECS #:VZ2540000
Fraction by Wt: 1 - 5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 MG/M3
ACGIH TLV:1 MG/M3; 9596
Ingred Name:P-METHYLAMINOPHENOL SULFATE (METOL)
CAS:55-55-1
RTECS #:SL8650000
Fraction by Wt: 1 - 5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:BORON OXIDE/BORIC ANHYDRIDE
CAS:1303-86-2
RTECS #:ED7900000
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3; 9596
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT): NOT GIVEN
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:BASED ON ANIMAL DATA, MAY CAUSE
ADVERSE EFFECTS ON BLOOD, KIDNEY, SPLEEN. HARMFUL IF
INHALED/SWALLOWED. AIRBORNE DUST IRRITATING. MAY LIBERATE SULFUR
DIOXIDE GAS WHICH IS IRRITATING TO RESPIRATORY TRA CT. EYE CONTACT
CAUSES BURNS. SKIN CONTACT CAUSES IRRITATION. MAY CAUSE ALLERGIC
SKIN REACTION/DEPIGMENTATION.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:BLOOD SYSTEM DAMAGE, KIDNEY DAMAGE, SPLEEN
DAMAGE, RESPIRATORY TRACT IRRITATION, DIFFICULT BREATHING, EYE
BURNS, SKIN IRRITATION, ALLERGIC SKIN REACTION, SKIN
DEPIGMENTATION, BURNS OF GASTROINTESTINAL TRACT, WHEEZING, CHEST
TIGHTNESS, STOMACH UPSET, HIVES, FAINTNESS, WEAKNESS, DIARRHEA.
Medical Cond Aggravated by Exposure:SOME ASTHMATICS OR HYPERSENSITIVE
INDIVIDUALS MAY EXPERIENCE WHEEZING, CHEST TIGHTNESS, STOMACH
UPSET, HIVES, FAINTNESS, WEAKNESS, DIARRHEA, DIFFICULT BREATHING.
======================= First Aid Measures =======================
First Aid:INHALATION: IF SYMPTOMATIC, MOVE TO FRESH AIR. GET MEDICAL
ATTENTION IF SYMPTOMS PERSIST. EYES: WASH OUT IMMEDIATELY WITH
WATER. GET MEDICAL ATTENTION IF SYMPTOMS OCCUR. SKIN: WASH WITH
SOAP AND WATER . GET MEDICAL ATTENTION IF SYMPTOMS OCCUR.
INGESTION: DO NOT INDUCE VOMITING. GIVE A GLASS OF WATER. CALL A
PHYSICIAN OR POISON CONTROL ASAP. NEVER GIVE ANYTHING BY MOUTH TO
AN UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:NONFLAMMABLE. USE EXTINGUISHING MEDIA SUITABLE FOR
SURROUNDING FIRE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING. FIRE OR EXCESSIVE HEAT MAY PRODUCE HAZARDOUS
DECOMPOSITION PRODUCTS.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH TO SEWER IF ALLOWABLE WITH LARGE AMOUNTS
OF WATER. OTHERWISE, SWEEP UP SPILL AND PLACE IN A CONTAINER FOR
CHEMICAL WASTE. CLEAN SURFACE TO REMOVE RESIDUAL CONTAMINATION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID BREATHING DUST. DO NOT GET IN
EYES & AVOID CONTACT WITH SKIN & CLOTHING. USE WITH ADEQUATE
VENTILATION. KEEP CONTAINER TIGHTLY CLOSED.
Other Precautions:KEEP AWAY FROM INCOMPATIBLE SUBSTANCES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF ENGINEERING CONTROLS DO NOT MAINTAIN AIRBORNE
CONCENTRATIONS BELOW RECOMMENDED EXPOSURE LIMITS, AN APPROVED
RESPIRATOR MUST BE WORN. RESPIRATOR TYPE: DUST. IF RESPIRATORS ARE
USED, A PROGRAM SHOULD BE INSTITUTED.
Ventilation:GOOD GENERAL VENTILATION, TYPICALLY 10 AIR CHANGES PER
HOUR, SHOULD BE USED. RATES SHOULD MATCH CONDITIONS.
Other Protective Equipment:CHEMICAL RESISTANT CLOTHING AS NECESSARY TO
PREVENT SKIN CONTACT. AN EMERGENCY EYEWASH AND SHOWER SHOULD BE
AVAILABLE.
Work Hygienic Practices:WASH HANDS THOROUGHLY WITH SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES.
Supplemental Safety and Health
REMOVE AND WASH CONTAMINATED CLOTHING BEFORE REUSE.
================== Physical/Chemical Properties ==================
HCC:N1
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:NOT GIVEN
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Decomp Temp:Decomp Text:NOT GIVEN
Vapor Pres:NEGLIGIBLE
Vapor Density:NOT GIVEN
Spec Gravity:NOT GIVEN
Viscosity:NOT RELEVANT
Evaporation Rate & Reference:NOT GIVEN
Solubility in Water:APPRECIABLE
Appearance and Odor:OFF-WHITE SOLID, NO ODOR
Percent Volatiles by Volume:NIL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
SULFUR DIOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT OR DISPOSAL MAY BE SUBJECT
TO NATIONAL, STATE OR LOCAL LAWS. MAY REQUIRE NEUTRALIZATION IF PH
< 2.0 OR PH > 12.5. DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE ANDLOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:1040/1045/1048/1050/5042/5052 DEVELOPER 5R5
CAGE:26921
CAGE:26921
============= Composition/Information on Ingredients =============
Ingred Name:IRON ; (IRON POWDER)
CAS:7439-89-6
RTECS #:NO4565500
Fraction by Wt: >95%
Ingred Name:POLYMETHYLMETHACRYLATE
CAS:9011-14-7
RTECS #:TR0400000
Fraction by Wt: <5%
Ingred Name:STYRENE, ACRYLATE COPOLYMER; (STYRENE/ACRYLATE POLYMER)
CAS:25213-39-2
Fraction by Wt: 85-90%
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: 10-15%
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3; 9192
Ingred Name:AMORPHOUS SILICA
CAS:7631-86-9
Fraction by Wt: <1%
OSHA PEL:6 MG/M3
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:ZINC STEARATE
CAS:557-05-1
RTECS #:ZH5200000
Fraction by Wt: <1%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50: ORL/RAT:>16G/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NONE WHEN USED AS DESCRIBED BY PRODUCT
LITERATURE.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:MINIMAL RESPIRATORY TRACT IRRITATION MAY OCCUR
AS WITH EXPOSURE TO LARGE AMOUNTS OF ANY NON-TOXIC DUST.
Medical Cond Aggravated by Exposure:NONE WHEN USED AS DESCRIBED BY
PRODUCT LITERATURE.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR AT LEAST 15 MIN. SKIN: WASH W/SOAP &
WATER. INHAL: REMOVE FROM EXPOSURE. INGEST: DILUTE STOMACH CONTACT
W/SEVERAL GLASSES OF WATER.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER, FOAM, DRY CHEMICAL
Fire Fighting Procedures:AVOID INHALATION OF SMOKE. WEAR PROTECTIVE
CLOTHING & NIOSH/MSHA APPROVED SCBA.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:IF SPILLED, SWEEP UP OR VACUUM.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE
Other Precautions:AVOID PROLONGED INHALATION OF EXCESSIVE DUST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED WHEN USED AS INTENDED IN XEROX
EQUIPMENT.
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:FOR USE OTHER THAN NORM CUSTOMER-OPER
PROC(SUCH AS BULK TONER PROCESSING FACILITIES),GOGS & RESPS MAY BE
REQ.(SUPP DATA)
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
OTHER PROT EQUPT: FOR MORE INFORMATION, CONTACT XEROX.
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity: 5
Appearance and Odor:BLACK GRANULAR/FAINT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:PRODUCTS OF COMBUSTION MAY BE TOXIC.
AVOID BREATHING SMOKE.
==================== Disposal Considerations ====================
Waste Disposal Methods:NO SPECIFIC WASTE DISPOSAL METHOD REQUIRED.
DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE, AND LOCAL
REGULATIONS.
| 0 | eyes_protection_not_mandatory |
===================== Product Identification =====================
Product ID:APCO 140
CAGE:4U202
CAGE:66172
CAGE:4U202
============= Composition/Information on Ingredients =============
Ingred Name:MEDIUM ALIPHATIC SOLVENT NAPHTHA
CAS:64742-88-7
Fraction by Wt: 100%
ACGIH TLV:25 PPM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:UNKNOWN Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and
Chronic:EYES/SKIN:IRRITATION;INHALATION:ANESTHETIC,IRRITATES
RESPIRATORY TRACT,MAY CAUSE SERIOUS NERVOUS SYSTEM
DEPRESSION;INGESTION:HARMFUL OR FATAL IF SWALLOWED.
Effects of Overexposure:SEE HEALTH HAZARDS
Medical Cond Aggravated by Exposure:RESPIRATORY AILMENTS.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH WITH PLENTY OF WATER FOR 15 MINUTES AND GET
MEDICAL ATTENTION;SKIN:FLUSH WITH PLENTY OF WATER;INHALATION:REMOVE
TO FRESH AIR,RESTORE BREATHING IF NEEDED;INGESTION:DO NOT INDUCE
VOMIT,CALL A PHYSICIAN IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:141F,60C
Lower Limits:0.9
Extinguishing Media:NFPA CLASS B EXTINGUISHERS (CO*2 OR FOAM) FOR CLASS
III A LIQUID FIRES.
Fire Fighting Procedures:USE SCBA. WATER SPRAY MAY BE INEFFECTIVE ON
FIRE,BUT CAN PROTECT FIREFIGHTERS AND COOL CLOSED CONTAINERS. USE
FOG NOZZLES IF WATER IS USED.
Unusual Fire/Explosion Hazard:COMBUSTIBLE! CLOSED CONTAINERS MAY
EXPLODE IF EXPOSED TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:ISOLATE FROM OXIDIZERS,HEAT AND OPEN FLAME.MOP
UP AND PLACE IN APPROPRIATE DISPOSAL CONTAINER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 120F,19C.STORE
LARGE AMOUNTS IN STRUCTURES MADE FOR OSHA CLASS IIIA LIQUIDS.AVOID
FREE FALL OF LIQUID.GROUND CONTAINERS WHEN POURNG
Other Precautions:DO NOT FLAME CUT,BRAZE OR WELD.EMPTY CONTAINERS ARE
HAZARDOUS.FOLLOW ALL LABEL PRECAUTIONS.KEEP CONTAINERS TIGHTLY
CLOSED.APPLYING TO HOT SURFACES REQUIRES SPECIAL PRECAUTIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF OVER TLV,USE SCBA.
Ventilation:VENTILATE TO KEEP BELOW 15PPM. LOCAL EXHAUST PREFERRABLE.
MECHANICAL (GENERAL),ACCEPTABLE.
Other Protective Equipment:NONE
Work Hygienic Practices:AVOID PROLONGED BREATHING OF VAPORS OR
MISTS.AVOID PROLONGED OR REPEATED CONTACT WITH SKIN.WASH AFTER
HANDLING.
Supplemental Safety and Health
BOILING RANGE:183-203C
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:361-398F
Vapor Pres:0.7
Vapor Density:5.2
Spec Gravity:0.787
Evaporation Rate & Reference:0.9 (ETHER=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR;WATER-WHITE
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS SUCH AS PERMANGANATES.
Stability Condition to Avoid:HEAT,OPEN FLAMES.
Hazardous Decomposition Products:CO
==================== Disposal Considerations ====================
Waste Disposal Methods:RECYCLE OR INCINERATE,OBSERVING FEDERAL,STATE
AND LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:SMART SOLUTIONS VOC-SAFE WINDSHIELD WASHER SOLVENT
CAGE:GO716
CAGE:GO716
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Ingred Name:NONYLPHENOL POLYOXYETHYLENE ETHER; POLYOXYETHYLENE
NONYLPHENOL; TERGITOL NPX; TRITON N-100; NONIONIC SURFACTANT
*98-1*
CAS:9016-45-9
RTECS #:MD0900000
Ingred Name:SODIUM LAURYL SULFATE, SODIUM LAURETH SULFATE *98-1*
CAS:151-21-3
RTECS #:WT1050000
Ingred Name:AMMONIUM HYDROXIDE, AQUA AMMONIA *98-1*
CAS:1336-21-6
RTECS #:BQ9625000
Other REC Limits:25 PPM
ACGIH TLV:25 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: SEVERE IRRITANT. INHALATION:
IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, DIFFICULTY BREATHING, GASTRIC PAIN,
VOMITING.
======================= First Aid Measures =======================
First Aid:SKIN: RINSE W/CLEAR WATER. EYES: FLUSH W/CLEAR RUNNING WATER
FOR 15 MINS. INHALATION: REMOVE TO FRESH AIR. INGESTION: DRINK
LARGE AMOUNTS OF WATER. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:CO2, DRY CHEMICAL, ALCOHOL FOAM.
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NON-FLAMMABLE.
================== Accidental Release Measures ==================
Spill Release Procedures:DILUTE W/WATER & FLUSH TO SANITARY SEWER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED WHEN NOT IN USE.
DON'T FREEZE. FOLLOW LABEL INSTRUCTIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOR EXPOSURE ABOVE LIMITS, USE NIOSH/MSHA
APPROVED DUST/MIST MASK.
Ventilation:RECOMMENDED
Other Protective Equipment:DRENCHING SHOWER, EYE WASH STATION.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F
Spec Gravity:1
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR BLUE LIQUID W/AMMONIA ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS/STRONG ACIDS.
Stability Condition to Avoid:HEAT, FREEZING.
Hazardous Decomposition Products:CO2 & CO.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:MARINE INBOARD-OUTBOARD MOTOR COLORS, ENAMELS 6988
Preparer's Name:W R MALLARNCE
CAGE:07778
CAGE:07778
CAGE:07708
============= Composition/Information on Ingredients =============
Ingred Name:ACETONE (SARA 313) (CERCLA) VP: 186 @ 20C
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 40-50%
OSHA PEL:1000 PPM
ACGIH TLV:750PPM/1000STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ACETIC ACID, ETHYL ESTER; (ETHYL ACETATE) (CERCLA) VP: 69 @
20C
CAS:141-78-6
RTECS #:AH5425000
Fraction by Wt: 0-5%
OSHA PEL:400 PPM
ACGIH TLV:400 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:PROPIONIC ACID, 3-ETHOXY-, ETHYL ESTER;
(ETHYL-3-ETHOXYPROPIONATE) VP: 0.67 @ 20C
CAS:763-69-9
RTECS #:UF3325000
Fraction by Wt: 0-5%
OSHA PEL:N/K
ACGIH TLV:50 PPM (MFR)
Ingred Name:ISOPROPYL ALCOHOL (SARA 313) VP: 33 @ 20C
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 0-5%
OSHA PEL:400 PPM
ACGIH TLV:400 PPM/500STEL
Ingred Name:2-BUTANONE; (METHYL ETHYL KETONE) (MEK) (SARA 313) (CERCLA)
VP: 70 @ 20C
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 0-5%
OSHA PEL:200 PPM
ACGIH TLV:200 PPM/300STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:2-PENTANONE, 4-METHYL; (METHYL ISOBUTYL KETONE) (HEXONE)
(SARA 313) (CERCLA) VP: 16 @ 20C
CAS:108-10-1
RTECS #:SA9275000
Fraction by Wt: 5-10%
OSHA PEL:100 PPM
ACGIH TLV:50 PPM/75 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:2-PROPANOL, 1-METHOXY-; (PROPYLENE GLYCOL MONOMETHYL ETHER)
VP: 8.0 @ 20C
CAS:107-98-2
RTECS #:UB7700000
Fraction by Wt: 0-5%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/150STEL
Ingred Name:HEXYL ACETATE; (OXO ALCOHOL ESTER) VP: 1.4 @ 20C
CAS:88230-35-7
Fraction by Wt: 0-5%
OSHA PEL:N/K
ACGIH TLV:50 PPM (MFR)
Ingred Name:TOLUENE (SARA 313) (CERCLA) VP: 22 @ 20C
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 5-10%
OSHA PEL:200 PPM
ACGIH TLV:50 PPM, S
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:HYDROCARBON PROPELLANT; (PROPANE/ISOBUTANE MIXTURE)
CAS:68476-86-8
Fraction by Wt: 19%
OSHA PEL:1000 PPM (MFR)
ACGIH TLV:N/K
Ingred Name:EFTS OF OVEREXP: CONSULTATION FROM APPROPRIATE HEALTH
PROFESSIONALS CONCERNING LATEST HAZARD LIST INFORMATION (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11: AND SAFE HANDLING AND EXPOSURE INFORMATION .
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL: EXCESS INHAL OF VAPS CAN
CAUSE NASAL & RESP IRRIT, DIZZ, WEAK, FATG, NAUS, HDCH, POSS UNCON
& EVEN ASPHY. EYE: CAN CAUSE SEV IRRIT, REDNESS, TEARING, BLURRED
VISION. INGEST: CAN CAUSE GI IRRIT, NAUS, VOMIT, DIARR. SKIN: CAN
CAUSE IRRIT FOR SOME PERS. CHRONIC: REPORTS HAVE ASSOC RPTD & (EFTS
OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: PRLNG OCCUP OVEREXP TO SOLV W/PERM
BRAIN & CNS DMG. SEV OVEREXP IN LAB ANIMALS HAS ALSO CAUSED LIVER
ABNORM & DMG TO KIDNEYS, LUNGS & SPLEEN, HEART & ADRENALS.
INTENTIONAL MISUSE BY DELIBERA TELY CONC & INHAL CONTENTS MAY BE
HARMFUL/FATAL. TOLUENE APPEARS ON NAVY LISTING OF OCCUP CHEM REPRO
HAZ. SEEK (ING 11)
Medical Cond Aggravated by Exposure:CAN CAUSE RESPIRATORY AND/OR SKIN
REACTION.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. IF BRTHG IS DFCLT, ADMIN OXYGEN.
IF BRTHG IS STOPPED, GIVE ARTF RESP & SEEK MED HELP. EYES: FLUSH
W/WATER FOR AT LEAST 15 MIN WHILE HOLDING EYELIDS OPEN. INGEST: DO
NOT IND UCE VOMIT (ASPIR OF MATL INTO LUNGS CANCAUSE PNEUMONIA,
WHICH CAN BE FATAL). KEEP PERS WARM, QUIET & GET MED ATTN/POIS CTL
CTR. SKIN: WASH W/SOAP & WATER/VARIOUS HAND CLEANERS & WASH
CLOTHING.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:0F,-18C
Lower Limits:1.0%
Extinguishing Media:USE ALCOHOL FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . WATER SPRAY MAY BE INEFFECTIVE. WATER MAY BE
USED TO COOL CLSD CONTRS TO PVNT PRESS (SUP DAT)
Unusual Fire/Explosion Hazard:CLSD CONTRS MAY EXPLODE &/AUTOIGNITE WHEN
EXPOS TO EXTREME HEAT. VAPS HVR/AIR & MAY TRAVEL ALONG GROUND/MAY
BE MOVED BY VENT & IGNITED BY PILOT (SUP DAT)
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES. VENTILATE
AREA. ABSORB LIQUID ON PAPER, VERMICULITE, FLOOR ABSORBENT OR OTHER
ABSORBENT MATERIAL AND TRANSFER TO A CLOSED CONTAINER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT PUNCTURE/INCIN. DO NOT STORE IN
AREAS > 120F/IN DIRECT SUNLIGHT/NEAR HEAT/OPEN FLAMES. STORE LGE
QTYS IN BLDG PROT FOR STOR OF FLAMM LIQS.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOR CASUAL/OCCASIONAL USE: TO AVOID BRTHG
VAPS/SPRAY MIST, OPEN WINDOWS & DOORS/USE OTHER MEANS TO ENSURE
FRESH AIR ENTRY DURING APPLICATN & DRYING. IF YOU EXPERIENCE EYE
WATERING, HDCH/DIZZ, INCR FRE SH AIR, WEAR NIOSH/MSHA APPRVD (SUP
DAT)
Ventilation:FOR REGULAR/CONTINUOUS USE: PROVIDE SUFFICIENT MECHANICAL
(GEN) AND/OR LOC EXHAUST VENT TO MAINTAIN EXPOSURE BELOW TLV.
Other Protective Equipment:WHERE SPEC/UNUSUAL CNDTNS EXIST, SEEK EXPERT
ASSIST OF IH. ANSI APPRVD EMER EYEWASH & DELUGE SHOWER .
Work Hygienic Practices:WASH HANDS BEFORE EATING OR USING WASHROOM. AS
WITH ALL CHEMICALS, MINIMIZE PERSONAL CONTACT.
Supplemental Safety and Health
FIRE FIGHT PROC: BUILD-UP & POSS AUTOIGNIT/EXPLO WHEN EXPOS TO EXTREME
HEAT. IF WATER USED, FOG NOZZ ARE PREFERABLE. EXPLO HAZ: LIGHTS,
OTHER FLAMES, SPARKS, HEATERS, SMKNG, ELEC MOTORS/OTHER LOCATION S
DISTANT FROM MATL HNDLG POINT. RESP PROT: RESPIRATORY PROTECTION
(TC23C OR EQUIVALENT), OR LEAVE THE AREA.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>133F,>56C
Melt/Freeze Pt:M.P/F.P Text:1500F,816C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:<1 (H*2O=1)
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:SLIGHT TO MODERATE
Appearance and Odor:TYPICAL SOLVENT PAINT
Percent Volatiles by Volume:80-90
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS AND HEAT.
Stability Condition to Avoid:HEAT, SPARKS AND OPEN FLAME.
Hazardous Decomposition Products:MAY FORM TOX MATLS, CARBON
DIOXIDE/CARBON MONOXIDE, VARIOUS HYDROCARBS, NITROGEN CMPDS, ETC,
WHEN BURNED.
==================== Disposal Considerations ====================
Waste Disposal Methods:MATERIAL COLLECTED ON ABSORBENT MATERIAL MAY BE
DEPOSITED IN A POSTED TOXIC SUBSTANCE LANDFILL IN ACCORDANCE WITH
LOCAL, STATE, AND FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:SPRED GLOSS EN RED PEPPER, 917
CAGE:72818
CAGE:72818
============= Composition/Information on Ingredients =============
Ingred Name:ORGANOPHILIC CLAY
CAS:68911-87-5
Fraction by Wt: 1%
Ingred Name:MINERAL SPIRITS;(HYDROCARBON SOLVENT). LEL:1%. VP:5 @ 77F.
CAS:64742-88-7
Fraction by Wt: 49%
OSHA PEL:500 PPM (MFR)
ACGIH TLV:100 PPM (MFR)
Ingred Name:MINERAL SPIRITS. LEL:.7%. VP:2 @ 68F.
CAS:64742-47-8
Fraction by Wt: 2%
OSHA PEL:500 PPM (MFR)
ACGIH TLV:100 PPM (MFR)
Ingred Name:ROSIN, MALEATED, POLYMER W/PENTAERYTHRITYOL;(MALEIC
MODIFIED ROSIN ESTER)
CAS:68333-69-7
Fraction by Wt: 1%
Ingred Name:ALKYD RESIN
CAS:68072-13-9
Fraction by Wt: 37%
Ingred Name:M-NITRO-P-TOLUIDINE-B-NAPHTHOL
CAS:2425-85-6
RTECS #:QK4270000
Fraction by Wt: 9%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:IRRIT OF EYES, SKIN, RESP TRACT.
PRLNGD INHAL MAY LEAD TO FATIGUE, DIZZ &/OR LIGHTHEADEDNESS, HDCH,
UNCOORDINATION, NAUS, CNS DEPRESS. PRLNGD/RPTD CONTACT CAN CAUSE
DERM, DEFAT, BLURRED VISION, TEARIN G OF EYES, REDNESS OF EYES,
POSS SENSITOF SKIN. INHAL, SKIN, OR EYE CONTACT &/OR INGEST MAY
CAUSE (EFTS OF OVEREXP)
Explanation of Carcinogenicity:MINERAL SPIRITS:RTECS LISTS IT AS IARC
ANIMAL LIMITED EVIDENCE CARCINOGEN.
Effects of Overexposure:HLTH HAZ:NAUSEA, VOMITING, DIARRHEA, DIGESTIVE
SYSTEM PROBLEMS, BLURRED VISION, TEARING OF EYES, CNS DEPRESSION,
ANESTHETIC EFFECT OR NARCOSIS, DIFFICULTY OF BRTHG, SEVERE LUNG
IRRIT OR DMG, UNCON. NO TICE-REPORTS HAVE ASSOCIATED RPTD/PRLNGD
OCCUPATIONAL OVEREXP TO SOLVS W/PERM BRAIN & NERV SYS DAMAGE. (SUPP
DATA)
Medical Cond Aggravated by Exposure:NOT DETERMINED.
======================= First Aid Measures =======================
First Aid:INHAL:MOVE TO FRESH AIR. RESTORE & SUPPORT CONTINUED BRTHG.
GET MD. GIVE O2 IF NEC. GET MD FOR ANY BRTHG DFCLTY. SKIN:WASH OFF
QUICKLY WITH PLENTY OF WATER, THEN SOAP & WATER; REMOVE
CONTAMINATED CLOT HING. WASH CONTAMINATED CLOTHING BEFOREREUSE.
EYE:FLUSH IMMEDIATELY WITH LARGE AMOUNTS OF WATER, ESPECIALLY UNDER
LIDS FOR AT LEAST 15 MINUTES. GET MD IMMEDIATELY. INGEST:GET MD
IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point:105F,41C
Lower Limits:.7
Extinguishing Media:DRY CHEMICAL OR FOAM.
Fire Fighting Procedures:WATER MAY BE USED TO COOL & PROTECT EXPOSED
CONTAINERS. WEAR NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:CLSD CNTNRS MAY EXPLODE WHEN EXPOSED TO
EXTREME HEAT/FIRE. VAPS CAN FORM EXPLOSIVE MIXTURES IN AIR AT
ELEVATED TEMPS. MAY DECOMPOSE UNDER FIRE CNDTNS(SUPP DATA)
================== Accidental Release Measures ==================
Spill Release Procedures:COMPLY W/ALL APPLIC HLTH & ENVIRONMENTAL REGS.
ELIMINATE ALL SOURCES OF IGNIT. VENT AREA. SPILLS MAY BE COLLECTED
W/ ABSORBENT MATLS. LARGE SPILLS-SHUT OFF LEAK IF SAFE TO DO SO.
DIKE & CNTN SPILL. PU MP TO STORAGE OR SALVAGE VESSELS. USE (SUPP
DATA)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE BELOW 100F. KEEP AWAY FROM HEAT,
SPARKS AND OPEN FLAME. USE ONLY WITH ADEQUATE VENTILATION. DO NOT
TAKE INTERNALLY.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. AVOID CONTACT W/SKIN &
EYES, & BRTHG OF VAPS. KEEP CNTNRS TIGHTLY CLOSED AND UPRIGHT WHEN
NOT IN USE. IF SANDING IS DONE, WEAR A DUST MASK TO AVOID BREATHING
OF SANDINGDUST. EMPTY CNTNRS MAY CNTN HAS RESIDUES
============= Exposure Controls/Personal Protection =============
Respiratory Protection:CONTROL ENVIRONMENTAL CONCENTRATIONS BELOW
APPLICABLE STANDARDS. WHERE RESPIRATORY PROTECTION IS REQUIRED, USE
ONLY NIOSH/MSHA APPROVED RESPIRATORS IN ACCORDANCE WITH STANDARD 29
CFR 1910.134.
Ventilation:PROVIDE DILUTION VENTILATION OR LOCAL EXHAUST TO PREVENT
BUILD UP OF VAPORS.
Other Protective Equipment:EYE WASH, SAFETY SHOWER.
Work Hygienic Practices:WASH HANDS THOROUGHLY AFTER HANDLING,
ESPECIALLY BEFORE EATING OR SMOKING.
Supplemental Safety and Health
EXPLO HAZ:EMITTING IRRITANT &/OR TOXIC GASES. EFTS OF
OVEREXP:INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING & INHALING
THE CONTENTS MAY BE HARMFUL OR FATAL. SPILL PROC:ABSORBENT TO PICK
UP EXCESS R ESIDUE. KEEP SALVAGE MATERIAL AND RINSEWATER OUT OF
SEWERS OR WATER COURSES.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:>308F,153C
Vapor Pres:SEE INGRED
Spec Gravity:0.92
Appearance and Odor:GREY LIQUID
Percent Volatiles by Volume:60.57
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS, ACIDS, BASES, AMINES.
Stability Condition to Avoid:ELEVATED TEMPERATURES, CONTACT WITH
OXIDIZING AGENT.
Hazardous Decomposition Products:CO, CO2.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH ALL APPLICABLE LOCAL,
STATE, AND FEDERAL REGULATIONS. AVOID DISCHARGE TO NATURAL WATERS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:IL-000 SERIES INDUSTRIAL LACQUER, IL111
Kit Part:Y
CAGE:FO883
CAGE:FO883
CAGE:76708
============= Composition/Information on Ingredients =============
Ingred Name:ISOPROPYL ALCOHOL (SARA III). VP:33MM @ 20C.
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 5-10%
OSHA PEL:400 PPM
ACGIH TLV:400 PPM/500STEL
Ingred Name:ETHANOL, 2-BUTOXY-; (2-BUTOXYETHANOL) (SARA III). VP:0.6 @
20C.
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: 25-45%
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM
Ingred Name:SOLVENT NAPHTHA-; (HEAVY AROMATIC NAPHTHA). VP:5 @ 200F
CAS:64742-94-5
RTECS #:WF3100000
Fraction by Wt: 0-18%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:VOLATILE ORGANIC CONTENT:638 G/L; 5.3 LB/GAL.
RTECS #:9999999VO
Fraction by Wt: 74%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ANIMAL STUDIES HAVE CLEARLY
DEMONSTRATED DOSE-RELATED ADVERSE EFTS ON THE CNS, HEMATOPOIETIC
TISS, BLOOD, KIDNEYS & LIVER ASSOC W/ADMIN OF ETHYLENE GLYCOL
MONOBUTYL ETHER (EGBE). (EXTRACTED FROM DHHS (NIOSH) PUB NO.
90-118) . ACUTE:INHAL:ANESTHETIC. IRRIT OF RESP TRACT/ACUTE NERV
SYS DEPRESS (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:CHARACTERIZED BY HEADACHE, DIZZINESS,
STAGGERING GAIT, CONFUSION, UNCONSCIOUSNESS/COMA. SKIN OR EYE
CONT:PRIMARY IRRITATION. RPTD & PRLNGD OVEREXPOSURE OF INHALATION
OR SKIN ABSORPTION MAY CA USE KIDNEY, LIVER, AND BLOOD DAMAGE.
======================= First Aid Measures =======================
First Aid:INHAL:FUMES:REMOVE FROM EXPOSURE. RESTORE BRTHG. KEEP WARM &
QUIET. NOTIFY PHYS. EYES:FLUSH IMMED W/COPIOUS QUANTITIES OF
RUNNING WATER FOR AT LEAST 15 MINUTES. TAKE TO PHYS FOR DEFINITIVE
MED TREATME NT. SKIN:REMOVE W/SOAP & WATER. REMOVE CONTAMD
CLOTHING. INGEST:DO NOT INDUCE VOMITING IF SWALLOWED.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:60.0F,15.6C
Lower Limits:2.0%
Extinguishing Media:FOAM, CO*2, DRY CHEMICAL.
Fire Fighting Procedures:NOT APPLICABLE. WEAR NIOSH/MSHA APPROVED SCBA
& FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM
HEAT, ELEC EQUIP, SPARKS, & OPEN FLAME. CLSD CNTNRS MAY EXPLO WHEN
EXPOS TO EXTREME HEAT. DO NOT APPLY TO HOT (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION (FLAMES, HOT
SURFACES, & ELECTRICAL, STATIC/FRICTIONAL SPARKS). AVOID BREATHING
VAPORS. VENTILATE AREA. REMOVE W/INERT, ABSORBENT AND NON-SPARKING
TOOLS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 120F. STORE LG QTYS
IN BUILDINGS DESIGNED FOR STORAGE OF NFPA CLASS IC FLAMM LIQUIDS.
DO NOT TAKE INTERNALLY.
Other Precautions:CNTNRS SHOULD BE GROUNDED WHEN POURING. AVOID FREE
FALL OF LIQUIDS IN EXCESS OF FEW INCHES. DO NOT FLAME CUT, BRAZE,
OR WELD WITHOUT MSHA OR NIOSH APPROVED RESPIRATOR OR APPROPRIATE
VENTILATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF VAP CONC EXCEEDS TLV LISTED IN INGREDS, USE
NIOSH/MSHA APPRVD RESPIRATORY W/ORGANIC CHEMICAL CARTRIDGE. CONSULT
REPUTABLE SAFETY SUPPLY COMPANY FOR PROPER RESPIRATOR SELECTION.
Ventilation:PROVIDE GEN DILUTION/LOC EXHAUST VENT IN VOL & PATTERN TO
KEEP TLV OF MOST HAZ INGRED BELOW ACCEPTABLE LIM, (SUPDAT)
Other Protective Equipment:PREVENT PROLONGED SKIN CONTACT
W/CONTAMINATED CLOTHING.
Work Hygienic Practices:WASH W/SOAP & WATER BEFORE EATING, SMOKING, OR
USING TOILET FACILITIES.
Supplemental Safety and Health
EXPLO HAZ:SURF. WATER SPRAY MAY BE INEFCTIVE. WATER MAY BE USED TO COOL
CLSD CNTNRS TO PVNT PRESS BUILDUP & POSS AUTOIGNIT/EXPLOS EXPO TO
EXTREME HEAT. IF WATER IS USED, FOG NOZZ ARE PREF. VENT:LEL IN
INGREDS STATED LIM, & TO REMOVE DECOMPPROD DURING WELDING/FLAME
CUTTING ON SURFACES COATED W/THIS PRODUCT.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>180F,>82C
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Spec Gravity:SEE INGRED
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NOT KNOWN
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:SEEING
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:MAY PRODUCE HAZ FUMES WHEN HEATED TO
DECOMP AS IN WELDING. FUMES MAY CONTAIN CARBON MONOXIDE & OXIDES OF
NITROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH APPLICABLE LOCAL,
COUNTY, STATE AND FEDERAL REGULATIONS. DO NOT INCINERATE CLOSED
CONTAINERS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:TREMOLITE ASBESTOS
CAGE:3A730
CAGE:3A730
============= Composition/Information on Ingredients =============
Ingred Name:FIBROUS TREMOLITE, TREMOLITE ASBESTOS (CONFIRMED HUMAN
CARCINOGEN BY ACGIH & IARC-GROUP 1, OSHA CANCER HAZARD) *96-1*
CAS:77536-68-6
RTECS #:CI6560000
Other REC Limits:5 FB/CC
OSHA PEL:0.2 F/CC
ACGIH TLV:2 FB/CC
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:YES
Health Hazards Acute and Chronic:INHALATION: MAY IRRITATE THE
RESPIRATORY TRACT. OVEREXPOSURE TO ASBESTOS HAS CAUSED DAMAGE TO
LUNGS(ASBESTOSIS), LUNG CANCER & MESOTHELIOMA OF THE PLEURA &
PERITONEUM, PLEURAL THICKENING, PLAQUES & EF FUSION. SKIN: ASBESTOS
SPLINTERS PENETRATE & CAUSE ASBESTOS CORNS. EYES: IRRITATION.
INGESTION: GI & LARYNGEAL CANCER.
Explanation of Carcinogenicity:SEE INGREDIENTS.
Effects of Overexposure:IRRITATION, DIFFICULTY IN BREATHING, CORNS,
ABRASIONS, LABORED BREATHING, CHEST PAINS, WEAKNESS, CHEST
TIGHTNESS.
Medical Cond Aggravated by Exposure:LUNG DISORDERS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. GIVE OXYGEN/CPR IF NEEDED.
SKIN: REMOVE ASBESTOS SLIVERS PROMPTLY. IF ASBESTOS CORN DEVELOPS,
SURGICAL REMOVAL MAY BE REQUIRED. EYES: IRRIGATE GENTLY W/WATER FOR
15 MI NS. OBTAIN MEDICAL ATTENTION IN ALL CASES. NOTES TO
PHYSICIAN: A MEDICAL SURVELLANCE PROGRAM MUST BE ESTABLISHED FOR
ASBESTOS-EXPOSED PERSONS FOR ASBESTOS.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE MEDIA APPROPRIATE FOR SURROUNDING MATERIAL IN
FIRE SITUATION.
Fire Fighting Procedures:AVOID MEDIA & PROCEDURES THAT CAUSE AIRBORNE
DUST. PERSONNEL INVOLVED IN FIRE FIGHTING SHOULD USE NIOSH/MSHA
APPROVED SCBA & FULL PROTECTION CLOTHING.
================== Accidental Release Measures ==================
Spill Release Procedures:AVOID BREATHING DUST. PERMIT ONLY TRAINED
CLEANUP PERSONNEL IN AREA. USE APPROVED RESPIRATORS & PROTECTIVE
CLOTHING. USE WET METHODS/APPROVED VACUUM CLEANING SYSTEM. USE
WATER/OTHER DUST SUPPRESSANTS WHERE SWEEPING IS UNAVOIDABLE. DON'T
STIR UP.
======================Handling and Storage ======================
Handling and Storage Precautions:FOR INDUSTRIAL USE ONLY. STORE
ASBESTOS IN CLOSED CONTAINERS(DUST TIGHT)IN A CLEAN, DRY SECURE
AREA. PROTECT CONTAINERS FROM DAMAGE.
Other Precautions:DON'T OPEN CONTAINERS THAT CAN RELEASE DUST W/O
PROPER ENCLOSURE/CONTROL MEASURES. USE DUST SUPPRESSION CONTROL
MEASURES AT STAGES OF ASBESTOS HANDLING, USE & DISPOSAL. AVOID
INHALATION OF ASBESTOS. D ON'T CREATE/BREATHE DUST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR: 10X
PEL-HALF-MASK AIR-PURIFYING RESPIRATOR W/HEPA FILTERS; 50X PEL-FULL
FACE PIECE AIR-PURIFYING RESPIRATOR W/HEPA FILTERS; 100X
PEL-POWERED AIR-PURIFYING RESPIRATOR W/ HEPA FILTERS OPERATED IN
CONTINUOUS FLOW
Ventilation:ADEQUATE EXHAUST & CAPTURE FILTRATION. HAND/POWER OPERATED
TOOLS MUST BE EQUIPPED W/LOCAL EXHAUST SYSTEMS.
Other Protective Equipment:FOR CONCENTRATIONS >OSHA PELS: COVERALLS,
REQUIRED.
Work Hygienic Practices:FOLLOW GOOD HOUSEKEEPING PRACTICES. DON'T TAKE
PROTECTIVE EQUIPMENT/CLOTHING HOME.
Supplemental Safety and Health
MELTING POINT: 2400F (FUSION POINT). SPILLS CONT'D: CLEANUP PERSONNEL
SHOULD WEAR APPROVED RESPIRATORS & PROTECTIVE CLOTHING. WASTE &
CONTAMINATED CLOTHING MUST BE PLACED IN DUST-TIGHT CONTAINERS & LA
BELED FOR DIPOSAL. WASTE CONT'D: DISPOSE WASTE CONTAINERS IN A
SECURED LANDFILL IAW/LOCAL, STATE & FEDERAL REGULATIONS.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:(SEE SUPP)
Spec Gravity:2.9-3.2
Solubility in Water:INSOLUBLE
Appearance and Odor:WHITE TO PALE GREEN W/RIGID FIBERS; ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:TEMP >2400F
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:BAGS, FRIABLE ASBESTOS, WASTE & SCRAP MATERIAL
SHOULD BE DISPOSED OF IN A MANNER WHICH WILL AVOID AIRBORNE
CONCENTRATIONS OF ASBESTOS. ASBESTOS IS CLASSIFIED AS HAZARDOUS
MATERIAL UNDER CWA 307 (A) & HAS A REPORATABLE QUANTITIY OF 1 LB.
(SEE SUPP)
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:HH-P-34C TY 2
Preparer's Name:HMIS TECHNICIAN
CAGE:5S153
CAGE:5S153
============= Composition/Information on Ingredients =============
Ingred Name:ASBESTOS, CHRYSOTILE
CAS:12001-29-5
RTECS #:CI6478500
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.2 FIBERS/CC
ACGIH TLV:2 FIBERS/CC; A1;9293
Ingred Name:COPPER (SARA III)
CAS:7440-50-8
RTECS #:GL5325000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.1MG/M3 FUME/1 DUST
ACGIH TLV:0.2MG/M3 FUME; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:GRAPHITE, NATURAL
CAS:7782-42-5
RTECS #:MD9659600
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15 MPPCF RDUST
ACGIH TLV:2 MG/M3 RDUST; 9293
Ingred Name:OIL
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE:MINOR EYS/SKIN IRRITATION.
INGESTION- IRRITATION OF GI TRACT. INHALATION-IRRITATION OF
RESPIRATORY TRACT. CHRONIC: ASBESTOSIS, LUNG CANCER, &
MESOTHELIOMA, ALL OF WHICH ARE DISABLING AND FATAL D ISEASES OF THE
LUNG. INHALATION AND INGESTION OF ASBESTOS FIBERS MAY CAUSE CANCER
OF THE BOWEL.
Explanation of Carcinogenicity:ASBESTOS IS A KNOWN HUMAN CARCINOGEN.
Effects of Overexposure:INHALATION: FATIGUE AND SHORTNESS OF BREATH
THAT GETS WORSE WITH TIME AND EVENTUALLY BECOMES DISABLING. EYES:
IRRITATION. SKIN: IRRITATION. INGESTION: MILD STOMACH DISTRESS.
DIARRHEA, VOMITING, AND NA USEA.
Medical Cond Aggravated by Exposure:ASTHMA, EMPHYSEMA, AND TUBERCULOSIS
ARE ALL GENERALLY AGGRAVATED BY EXPOSURE TO ASBESTOS FIBERS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. SEE DOCTOR. EYES: RINSE
THOROUGHLY WITH WATER FOR 15 MINUTES. SEE DOCTOR. SKIN: WASH
THOROUGHLY WITH SOAP AND WATER. IF IRRITATION PERSISTS, SEE DOCTOR.
INGESTION: DIL UTE WITH WATER. DO NOT INDUCE VOMITING.SEE DOCTOR.
===================== Fire Fighting Measures =====================
Flash Point:NOT REQUIRED
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:VACUUM THE MATERIAL WITH A HEPA FILTERED
VACUUM. THE EQUIPMENT SHALL BE USED & EMPTIED SO AS TO MINIMIZE THE
RE-ENTRY OF ASBESTOS INTO THE WORKPLACE. OTHERWISE, WET THE
MATERIAL WITH WATER & SURFACTAN T AND THEN SHOVEL OR MOP UP
CONTAMINATION.
======================Handling and Storage ======================
Handling and Storage Precautions:ITEM IS NONFRIABLE & WILL NOT SHED
FIBERS IN NORMAL USE AND STORAGE. USED ITEMS SHALL BE WETTED
BEFORE, DURING & AFTER DISASSEMBLY.
Other Precautions:IF IT IS NECESSARY TO CUT OR IMPACT THE ITEM WHILE
INSTALLING IT, WEAR A RESPIRATOR AND PROTECTIVE CLOTHING. USED
ITEMS SHALL BE IDENTIFIED AND DISPOSED OF IN ACCORDANCE WITH ALL
LOCAL, STATE AND FEDE RAL REGULATIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR A NIOSH/MSHA APPROVED HEPA RESPIRATOR IF
REQUIRED. WEAR SELF-CONTAINED BREATHING APPARATUS IF REQUIRED FOR
HIGH LEVELS OF CONTAMINATES.
Ventilation:LOCAL EXHAUST SUFFICIENT TO ENTRAIN ALL PARTICULATE
EMISSIONS. HEPA FILTER REQUIRED. NO LEAKS ON PRESSURE SIDE OF FAN.
Other Protective Equipment:USE COVERALLS OR DISPOSABLE CLOTHING.
Work Hygienic Practices:WET WORK TO THE DEGREE POSSIBLE. WASH HANDS
AFTER HANDLING ITEM. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
MSDS GENERATED BY HMIS TECHNICIAN. WHEN HMIS IS ABLE TO OBTAIN AN MSDS
FROM MANUFACTURER, THIS RECORD WILL BE UPDATED. INGREDIENTS ARE
FROM DLSC TIR PART M OR PARTSMASTER TECHNICAL CHARACTRISTICS AND
MIL-SPEC.
================== Physical/Chemical Properties ==================
HCC:T6
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BRAIDED, ASBESTOS AND COPPER PACKING MATERIAL
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG MINERAL ACIDS, AND STRONG ALKALIS
Stability Condition to Avoid:ACCUMULATIONS OF DUST
Hazardous Decomposition Products:ASBESTOS DUST
==================== Disposal Considerations ====================
Waste Disposal Methods:WET THE MATERIAL WITH WATER AND SURFACTANT.
PLACE IN 6 MIL THICK POLYETHYLENE PLASTIC BAG. PLACE THESE BAGS
INTO ANOTHER POLY BAG OR A SAFE PLACE UNTIL IT CAN BE SHIPPED TO AN
APPROVED DISPOSAL SITE. IDENTIFY WITH ASBESTOS CANCER WARNING
LABEL.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:M060371 FAST DRYING POLYURETHANE CLEAR SEMI-GLOSS
CAGE:EO256
CAGE:EO256
CAGE:0K1A4
============= Composition/Information on Ingredients =============
Ingred Name:MEDIUM ALIPHATIC NAPHTHA (AROMATIC 100), PARAFFIN-NAPTHANES
MINERAL SPIRITS * 96-3 *
CAS:64742-88-7
Fraction by Wt: 20-26%
Other REC Limits:100 PPM
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
Ingred Name:STODDARD SOLVENT (PETROLEUM DISTILLATE), MINERAL SPIRITS
* 96-3 *
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 29-40%
Other REC Limits:525 MG/CUM
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
Ingred Name:VOLATILE ORGANIC CONTENT: 540 GM/L
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: IRRITATION. INGESTION:
HARMFUL/FATAL.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION
Medical Cond Aggravated by Exposure:PRE-EXISTING LUNG DISORDERS.
======================= First Aid Measures =======================
First Aid:INHALATION: IMMEDIATELY MOVE TO FRESH AIR. SKIN: WASH
THOROUGHLY W/SOAP & WATER. EYES: FLUSH W/PLENTY OF WATER.
INGESTION: DON'T INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:>101F
Extinguishing Media:WATER SPRAY, FOAM, DRY CHEMICAL/CO2
Fire Fighting Procedures:WEAR SELF CONTAINED BREATHING APPARATUS &
PROTECTIVE CLOTHING. USE WATER SPRAY TO COOL FIRE-EXPOSED
CONTAINERS. DON'T USE DIRECT STREAM OF WATER.
Unusual Fire/Explosion Hazard:PRODUCT MAY FLOAT & CAN BE REIGNITED ON
SURFACE OF WATER. CONTAINERS EXPOSED TO INTENSE HEAT FROM FIRE MAY
CAUSE VAPOR PRESSURE BUILDUP & RUPTURE CONTAINERS.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL: ABSORB W/SAND/OTHER SUITABLE ABSORBENT
MATERIAL & PLACE IN A CONTAINER FOR DISPOSAL. LARGE: AREA MAY BE
SLIPPERY, DIKE W/ABSORBENT MATERIAL. TRANSFER LIQUIDS &
CONTAMINATED DIKING MATERIAL TO S EPARATE, SUITABLE CONTAINERS FOR
RECOVERY/DISPOSAL
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T USE/STORE NEAR HEAT, SPARKS,
FLAME/OTHER SOURCES OF IGNITION. CLOSE CONTAINER AFTER EACH USE.
KEEP OUT OF REACH OF CHILDREN.
Other Precautions:AVOID CONTACT W/SKIN/EYES. AVOID INHALATION & USE
ONLY W/ADEQUATE VENTILATION. DON'T TAKE INTERNALLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF ADEQUATE VENTILATION CAN'T BE MAINTAINED,
WEAR RESPIRATORY PROTECTION (NIOSH/MSHA TC23C)/LEAVE THE AREA.
Ventilation:ADEQUATE VENTILATION
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Spec Gravity:0.861
Solubility in Water:INSOLUBLE
Appearance and Odor:CLEAR AMBER LIQUID W/HYDROCARBON ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:INTENSE HEAT, SPARKS, FIRE/FLAME & OTHER
IGNITION SOURCES
Hazardous Decomposition Products:HYDROCARBON FUMES, SMOKE, CO.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:5780 DEEP TINT BASE
CAGE:01PD6
CAGE:01PD6
============= Composition/Information on Ingredients =============
Ingred Name:CALCIUM CARBONATE, DOMOLITE, LIMESTONE, WHITING *96-2*
CAS:1317-65-3
RTECS #:EV9580000
Fraction by Wt: 20-30%
ACGIH TLV:10 MG/CUM (DUST)
Ingred Name:CLAY (KAOLIN), ALUMINUM SILICATE *96-2*
CAS:1332-58-7
RTECS #:GF1670500
Fraction by Wt: 1-5%
ACGIH TLV:10 MG/CUM TOTAL DUST
Ingred Name:STODDARD SOLVENT (PETROLEUM DISTILLATE), MINERAL SPIRITS
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 1-5%
Other REC Limits:525 MG/CUM
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
Ingred Name:MEDIUM ALIPHATIC NAPHTHA (AROMATIC 100), PARAFFIN-NAPTHANES
MINERAL SPIRITS
CAS:64742-88-7
Fraction by Wt: 5-40%
Other REC Limits:100 PPM
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
Ingred Name:CRYSTALLINE-QUARTZ SILICA, SILICA DUST (SUSPECTED HUMAN
CARCINOGEN BY IARC-GROUP 2A; SUSPECTED CARCINOGEN NTP) *96-2*
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 10-20%
Other REC Limits:0.05 MG/CUM (NIOSH)
OSHA PEL:10 MG/CUM %RESP SIO2
ACGIH TLV:0.1 MG/CUM RESP DUST
Ingred Name:TITANIUM DIOXIDE, TITANIUM OXIDE (SUSPECTED ANIMAL
CARCINOGEN, IARC GROUP 3)*96-2*
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 1-5%
OSHA PEL:15 MG/CUM
ACGIH TLV:10 MG/CUM (DUST)
Ingred Name:ALKYD RESIN
Fraction by Wt: 10-20%
Ingred Name:FATTY ACIDS, TALL-OIL, POLYMER W/GLYCEROL, PENTAERYTHRITOL
& PHTHALIC ANHYDRIDE *96-1*
CAS:66070-62-0
Fraction by Wt: 1-5%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHALATION: IRRITATION TO RESPIRATORY
TRACT & MUCOUS MEMBRANES. CNS DEPRESSION. MAY CAUSE RESPIRATORY
PROBLEMS/ANESTHETIC EFFECTS, SEVERE LUNG IRRITATION/DAMAGE,
PNEUMOCONIOSIS, ASPHYXIATION & DEATH. SKIN: IRRITATION,
DERMATITIS, ABSORPTION, CNS DEPRESSION/DEATH. EYES: IRRITATION.
(SEE SUPP)
Explanation of Carcinogenicity:SEE INGREDIENTS.
Effects of Overexposure:IRRITATION/LOSS OF
APPETITE/FATIGUE/DROWSINESS/DIZZINESS/LIGHTHEADEDNESS/HEADACHE/UNCO
ORDINATION/NAUSEA/COUGHING/SNEEZING/INTOXICATION/CONFUSION/NARCOSIS
/DIFFICULTY BREATHING/TREMORS/CONVULSIONS/LOSS OF
CONSCIOUSNESS/ASPHYXIATION/DEFATTING/BLURRED
VISION/TEARING/REDNESS/INFLAMMATION/VOMITING/DIARRHEA/GI
DISTURBANCES.
Medical Cond Aggravated by Exposure:EYE, SKIN, RESPIRATORY DISORDERS,
LUNG DISORDERS & ASTHMA-LIKE CONDITIONS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE & SUPPORT CONTINUED
BREATHING. HAVE TRAINED PERSON GIVE OXYGEN. SKIN: FLUSH W/WATER.
WASH THOROUGHLY W/SOAP & WATER. EYES: FLUSH IMMEDIATELY W/LARGE
AMOUNTS OFWATER. OBTAIN MEDICAL ATTENTION IN ALLCASES.
===================== Fire Fighting Measures =====================
Flash Point:105F
Extinguishing Media:DRY CHEMICAL/FOAM, WATER FOG, CO2
Fire Fighting Procedures:WATER MAY BE USED TO COOL & PROTECT EXPOSED
CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY BURST/EXPLODE WHEN
EXPOSED TO EXTREME HEAT/FIRE. VAPORS ARE >AIR & MAY TRAVEL LONG
DISTANCES TO AN IGNITION SOURCES & FLASHBACK. (SEE SUPP
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE IGNITION SOURCES. VENTILATE
W/EXPLOSION-PROOF EQUIPMENT. EVACUATE. PLACE COLLECTED MATERIAL IN
PROPER CONTAINER. USE PROTECTIVE EQUIPMENT. LARGE: SHUT OFF LEAK.
DIKE/CONTAIN. PUMP TO STORAGE /SALVAGE VESSELS. PICK UP RESIDUE
W/ABSORBENT.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE <100F. KEEP AWAY FROM IGNITION
SOURCES. KEEP CONTAINERS TIGHTLY CLOSED & UPRIGHT WHEN NOT IN USE.
GROUND EQUIPMENT WHEN TRANSFERRING.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. DON'T TAKE INTERNALLY.
AVOID CONTACT W/SKIN, EYES & BREATHING OF VAPORS. PREVENT
ACCUMULATION OF STATIC CHARGE. USE ONLY W/ADEQUATE VENTILATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHERE REQUIRED, USE ONLY NIOSH/MSHA APPROVED
RESPIRATORS IAW/OSHA STANDARD 29 CFR 1910.134. USE APPROPRIATE
RESPIRATORY PROTECTION WHERE FORMATION OF INHALABLE PARTICLES SUCH
AS SPRAYING/ABRADING/SAND ING PAINTED SURFACES.
Ventilation:DILUTION VENTILATION/LOCAL EXHAUST TO PREVENT BUILDUP OF
VAPORS. USE EXPLOSION-PROOF EQUIPMENT.
Other Protective Equipment:IMPERVIOUS CLOTHING, APRON, BOOTS, EYE WASH,
SAFETY SHOWER
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:284-428F
VOC Pounds/Gallon:459
Appearance and Odor:DEEP TINT BASE
Percent Volatiles by Volume:58.84
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS, ACIDS, BASES, AMINES, ALUMINUM, ZINC, HYDROGEN FLUORIDE,
MAGNESIUM, SODIUM, POTASSIUM
Stability Condition to Avoid:ELEVATED TEMPS, SPARKS, OPEN FLAME, STATIC
CHARGE & OTHER IGNITION SOURCES
Hazardous Decomposition Products:CO, CO2, OXYGEN, TOXIC GASES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS. KEEP SALVAGEABLE MATERIAL & RINSE WATER OUT OF
SEWERS & WATERCOURSES. AVOID DISCHARGE TO NATURAL WATERS.
COMBUSTIBLE LIQUID UN1263.
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:131030-00627 VARSOL 1
Preparer's Name:MARKETING TECHNICAL SER
CAGE:29700
CAGE:29700
============= Composition/Information on Ingredients =============
Ingred Name:STODDARD SOLVENT
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 100%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:500 PPM
ACGIH TLV:100 PPM; 9495
Ingred Name:C*7-C*10 SATURATED HYDROCARBON
Fraction by Wt: 83.0%
Other REC Limits:NONE RECOMMENDED
Ingred Name:1,2,4-TRIMETHYLBENZENE (SARA 313)
CAS:95-63-6
RTECS #:DC3325000
Fraction by Wt: 4.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:25 PPM
ACGIH TLV:25 PPM; 9495
Ingred Name:C8+ AROMATICS
Fraction by Wt: 17.0%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RABBIT) >3.16G/KG OF BODY WT
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN:REMOVE
OILS,IRRIT,DERM.EYE:IRRIT.INGEST:LOW ORDER OF ACUTE ORAL/DERM
TOX.MINUTE AMTS ASPIRATED INTO LUNGS DURING INGEST/VOMIT CAUSE
MILD-SEVERE PULM INJURY,POSSIBLY DEATH.
Effects of Overexposure:HIG VAP CONCE(>1000PPM)IRRIT EYE,RESP
TRACT.CAUSE HEAD,DIZZ,ANESTHESIA,DROWS,UNCONSC,OTHER CNS EFFECTS
INCLUDING DEATH.
Medical Cond Aggravated by Exposure:PETROL SOLVTS/PETO
HYDROCARBONS-SKIN CONTACT MAY AGGRAVATE EXISTING DERMATITIS.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH W/CLEAR WATER FOR 15MINS/TIL IRRI SUBSIDES.IRRIT
PERSISTS CALL PHYSICIAN. SKIN:REMOVE CONTAMIN CLOTH.WASH SKIN
W/SOAP/WATER.IF INJECTED INTO/UNDER SKIN/INTO ANY PART OF BODY
EVALUATE IMMED B Y DR AS SURGICAL EMERG.EARLY SURGICAL TREAT W/IN
1ST FEW HRS MAY SIGNIFICANTLY ULTIMATE EXTENT OF INJURY.
INHAL:REMOVE FRM EXPO.CALL PHYSICIAN IMMED.BREATH IRREG/STOP START
RESUSCIT,ADMIN OXY. (SUPPL)
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:104F,40C
Autoignition Temp:Autoignition Temp Text:254C
Lower Limits:2.1
Upper Limits:13.3
Extinguishing Media:FOAM,H2O SPRAY(FOG),DRY CHEM,CO2,VAP LIQ TYP EXT
AGENT.H2O MAY BE INEFFECTIVE.PLAN FIRE PROT/RESP STRATEGY THRU
COMMUNIT
Fire Fighting Procedures:KEEP FIRE-EXPO CNTNRS COOL W/H2O.DISPERSE
VAP/PROTECT MEN STOP LEAK,FLUSH SPILLS AWAY FRM EXPO W/H2OSPRAY.MIN
BREATH GAS/VAP/FUMES/DECOMPPO PROD.SUP-AIR BREATH
Unusual Fire/Explosion Hazard:LIQ IS VOLATILE/GIVE OFF INVISIBLE
VAP;MAY SETTLE IN LOW AREAS/TRAVEL SOME DISTANCE ALONG
GROUND/SURFACE TO IGN SOURCES;MAY IGN/EXPLO.
================== Accidental Release Measures ==================
Spill Release Procedures:SHUT OFF.ELIMNATE IGN SOURCES.KEEP PEOPLE
AWAY.RECOVER FREE PORD.ADD SAND/EARTH/SUITABLE ABSORBENT.MIN BREATH
VAP/SKIN CONTACT.VENTI CONFINED SPACES.OPN WINDOWS/DOORS.KEEP OUT
OF SEWERS/WATERCOURSES W /DIKE/IMPOUND.CONFORM TO APPLICABLE GOVT
REGS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CNTNR CLSD WHEN NOT IN USE.DO NOT
STORE NEAR HEAT/SPARKS/FLAME/STRONG OXID.EFFECTIVELY GROUND PROD
TRANS SYS IAW NFPA.USE APPROP EQMPT.NFPA-70.
Other Precautions:EMPTY CNTNR RETAIN RESIDUE-DANGEROUS.DO NOT
PRESSURIZE/CUT/WELD/BRAZE/SOLDER/DRILL/GRIND/EXPO TO
HEAT/FLAME/SPARKS/STATIC ELECTR/IGN SOURCES-MAY
EXPLO/INJURY/DEATH.REFER:ANSI Z49.1/OTHER GOVT REGS FOR
CLEAN/REPAIR/WELD/CONTEMPLATE OPERATION
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SPECIFIED BY MANUFACTURER.
Ventilation:USE ONLY W/VENTI SUFFICTO PREVENT EXCEEDING RECOMMENDED
EXPO LIMIT/BUILUP OF EXPLO CONCEN.NO SMOKE/FLAME USE/IGN SOURCE.
Other Protective Equipment:CHEM-RESIST APRON/OTHER IMPERV CLOTH IF
NEEDED.WATERLESS HANDCLEANERS FOLLOWED BY WASHING WELL
W/SOAP/WATER.
Work Hygienic Practices:MIN BREATH VAP/MIST.LAUNDER/DRYCLEAN CONTAMIN
CLOTH/SHOES BEF REUSE.CLEAN WELL BEF MEALS/BREAKS/END @WORK PER.
Supplemental Safety and Health
1STAID:INGEST:DO NOT INDUCE VOMIT.CALL PHYSICIAN IMMED. DISPO:SURFACE
WATER(CAUSE SHEEN).
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:315F,157C
Melt/Freeze Pt:M.P/F.P Text:<0F,<-18C
Vapor Pres:1.6MM @20C
Vapor Density:3.5
Spec Gravity:0.80
pH:NEUTRA
Viscosity:1.25CST @25C
Evaporation Rate & Reference:0.1 (N-BUTYL ACETATE=1)
Solubility in Water:NELGIGIBLE, 0.005%
Appearance and Odor:CLEAR WATER-WHITE LIQUID, MINERAL SPIRITS ODOR.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDANTS SUCH AS LIQ CHLORINE, CONCEN OXY, SODIUM HYPOCHLORITE,
CALCIUM HYPOCHLORITE, ETC-PRESENTS SER EXPLO HAZ.
Stability Condition to Avoid:KEEP PRODUCT AWAY FRM IGN SOURCES SUCH AS
HEAT,SPARKS,PILOT LIGHTS,STATIC ELECTRICITY,OPN FLAME.
Hazardous Decomposition Products:FUMES,SMOKE,CO,SULFUR
OXIDES,ALDEHYDES,OTHER DECOMPO PROD IN CASE OF INCOMPLETE
COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT CLEAN EMPTY CNTNR-RESIDUE DIFF TO
REMOVE;DRAIN COMPLETELY/PROPERLY BUNGED/RETURN TO DRM
RECONDITIONER.ALL OTHER CNTNR DISPO IN ENVIR SAFE MANNER IAW GOVT
REGS.PROD OIL.REPORT TO NAT RESP CNTRN 800-424-8802 IF
DISCHARGE/SPILL INTO/LEAD TO(SUPP)
| 1 | eyes_protection_mandatory |
=======================================================
Product ID: T-17 URETHANE THINNER, 01710000
Cage: 1HK86
=======================================================
Contractor Summary
=======================================================
Cage: 1HK86
Box: 7600
=======================================================
Ingredients
=======================================================
Cas: 763-69-9
RTECS #: UF3325000
1.5
% Wt: 100
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
RTECS #: 9999999VO
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
ATTENTION.
-----------------------------
INHALING THE CONTENTS MAY BE HARMFUL OR FATAL.
-----------------------------
UNTIL PROPERLY DISPOSED OF.
-----------------------------
PORTIONS WILL HAVE HAZ OF BOTH COMPONENTS.
-----------------------------
CHEMICAL KNOWN TO THE STATE OF CALIFORNIA
-----------------------------
(PROPOSITION 65).
-----------------------------
CHEM/MECH FILTER DESIGNED TO REMOVE A
-----------------------------
AREAS, WEAR NIOSH/MSHA APPRVD AIR SUPP RESP/USE
-----------------------------
BRAZING & SANDING MATL COATED W/THIS PROD.
-----------------------------
SANDING DUST OF DRIED COATINGS & DECOMP PROD
-----------------------------
VAPS MAY SPREAD LONG DIST. PVNT BUILD-UP BY
-----------------------------
ELIMINATE ALL IGNITION SOURCES.
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: LD50 (ORAL RAT): 4.3 G/KG.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE: INHAL: IRRIT OF RESP TRACT, HDCH, NAUS, DIZZ, WEAK
& FATG. EXTREME EXPOS CAN RSLT IN UNCON & EVEN RESP ARREST. SKIN/EYE:
IRRIT. MAY BE HARMFUL IF ABSORBED THRU SKIN. INGEST: CAN CAUSE STOM &/IN
TESTINAL IRRIT, NAUS, VOMIT & DIARR. CHRONIC: REPORTS HAVE ASSOC RPTD
& PRLNG OCCUP OVEREXP TO SOLV (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: HLTH HAZ: W/PERM BRAIN & NERV SYS DMG.
PRLNG/RPTD BRTHG OF SPRAY MIST &/SANDING DUST OVER PERIOD OF YEARS MAY
CAUSE DUST DISEASE OF LUNGS.
Medical Cond Aggravated By Exposure: NONE, WHEN USED IN ACCORDANCE WITH SAFE
HANDLING AND USE INFORMATION.
First Aid: INHAL: IF DFCLT BRTHG, OBTAIN FRESH AIR. IF CONTINUED DFCLT
EXPERIENCED, SUMMON MED ASSIST IMMED. IF BRTHG CEASES, RESTORE USING APPRVD
CPR TECHNIQUES & SUMMON MED HELP IMMED. EYE: FLUSH IMMED W/LGE A MTS OF
WATER FOR AT LEAST 15 MIN. GET MED ASSIST. SKIN: WASH AFFECTED AREAS W/SOAP
& WATER. REMOVE SOILED CLTHG. GET MED ASSIST IF IRRIT PERSISTS. INGEST:
CONSULT MD IMMED.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: REMOVE ALL SOURCES OF IGNIT (FLAMES, HOT SURF, &
ELEC, STATIC/FRICTIONAL SPARKS). PVNT BRTHG OF VAPS. VENT AREA. BEFORE
ATTEMPTING CLEAN-UP, REFER TO HAZ CAUTION INFO IN OTHER SECTIONS OF THIS
MSDS. C ONTAIN SPILLED MATL & REMOVE W/INERT
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS. INCINERATE ONLY IN APPROVED FACILITY. DO NOT INCINERATE CLOSED
CONTAINERS.
Handling And Storage Precautions: KEEP AWAY FROM HEAT, SPARKS & FLAMES. DO
NOT SMOKE. PVNT BUILD-UP OF VAPS BY MAINTAINING CONTINOUS FLOW OF FRESH AIR.
DO NOT GET ON SKIN/EYES.
Other Precautions: DO NOT STORE >120F/NEAR FIRE/OPEN FLAME. STORE LGE QTYS
IN BLDGS TO COMPLY W/OSHA 1910.106. KEEP CONTR CLSD WHEN NOT IN USE. DO NOT
TRANSFER CONTENTS TO BOTTLES/OTHER UNLABELLED CONTRS. DO NOT REUSE E MPTY
CONTRS. IF THIS MATL IS
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: SCC
Flash Point Text: 136F,58C
Lower Limits: 1.05%
Extinguishing Media: USE CARBON DIOXIDE, DRY CHEMICAL, FOAM OR OTHER NFPA
APPROVED METHOD FOR TREATING A CLASS B FIRE.
Fire Fighting Procedures: WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP (FP
N). SUMMON PROFESSIONAL FIREFIGHTERS. WATER SPRAY MAY BE INEFFECTIVE. IF
WATER IS USED, FOG NOZZ ARE (SUP DAT)
Unusual Fire/Explosion Hazard: KEEP CONTRS TIGHTLY CLSD. ISOLATE FROM HEAT,
ELEC EQUIP, SPARKS & FLAME. DUE TO PRESS BUILD-UP, CLSD CONTRS EXPOSED TO
EXTREME HEAT MAY EXPLODE. NEVER (SUP DAT)
=======================================================
Control Measures
=======================================================
Respiratory Protection: DO NOT BREATHE VAPS, SPRAY MIST/SANDING DUST. WHEN
SPRAY APPLIED IN OUTDOORS/OPEN AREAS, & DURING SANDING/GRINDING
OPERATIONS, USE NIOSH/MSHA APPRVD MECH FILTER RESP TO REMOVE SOLID AIRBORNE
PARTICLES OF OVERSPRAY & SANDING DUST.
Ventilation: PROVIDE GEN DILUTION/LOC EXHAUST VENT IN VOL & PATTERN TO KEEP
AIR CONTAM CONC BELOW CURRENT APPLIC SFTY & HLTH
Other Protective Equipment: SOLVENT IMPERMEABLE CLOTHING AND BOOTS. EMERGENCY
EYEWASH & DELUGE SHOWER MEETING ANSI DESIGN CRITERIA (FP N).
Work Hygienic Practices: REMOVE AND WASH SOILED CLOTHING BEFORE REUSE. WASH
HANDS BEFORE EATING OR SMOKING.
Supplemental Safety and Health: FIRE FIGHT PROC: PREFERABLE. IF EXPOSED TO
FIRE/EXTREME HEAT, WATER SHOULD BE USED TO COOL CLSD CONTRS & PVNT PRESS
BUILD-UP/POSS AUTO-IGNIT. EXPLO HAZ: USE WELDING/CUTTING TORCH ON/NEAR CONTR
(EVEN E MPTY) AS PROD/ITS RESIDUE MAY IGNITE. DURING EMER CNDTNS OVEREXP TO
DECOMP PROD MAY CAUSE HLTH HAZ.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: 329F,165C
Vapor Pres: SEE ING 1
Vapor Density: HVR/AIR
Spec Gravity: 0.94 (FP N)
Evaporation Rate & Reference: SLOWER THAN ETHER
Appearance and Odor: NONE SPECIFIED BY MANUFACTURER
Percent Volatiles by Volume: 100
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: AVOID CONTACT WITH STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products: MAY CAUSE TOXIC FUMES WHEN HEATED TO
DECOMPOSITION. FUMES MAY CONTAIN CARBON MONOXIDE, CARBON DIOXIDE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: T-17 URETHANE THINNER, 01710000
Cage: 1HK86
Company Name: DEVOE COATINGS CO
Street: 4000 DUPONT CIRCLE
PO Box: 7600
Zipcode: 40207-4802
Label Required IND: Y
Date Of Label Review: 02/02/1996
Status Code: C
Label Date: 02/02/1996
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Slight
Fire Hazard: Moderate
Reactivity Hazard: None
Hazard And Precautions: COMBUSTIBLE. ACUTE: INHALATION: IRRITATION OF
RESPIRATORY TRACT, HEADACHE, NAUSEA, DIZZINESS, WEAKNESS AND FATIGUE. EXTREME
EXPOSURE CAN RESULT IN UNCONSCIOUSNESS AND EVEN RESPIRATORY ARREST. SKIN/EYE
: IRRITATION. MAY BE HARMFUL IF ABSORBED THROUGH THE SKIN. INGESTION: CAN
CAUSE STOMACH AND/OR INTESTINAL IRRITATION, NAUSEA, VOMITING AND DIARRHEA.
CHRONIC: REPORTS HAVE ASSOCIATED REPEATED AND PROLO NGED OCCUPATIONAL
OVEREXPOSURE TO SOLVENTS WITH PERMANENT BRAIN AND NERVOUS SYSTEM DAMAGE.
PROLONGED OR REPEATED BREATHING OF SPRAY MIST AND/OR SANDING DUST OVER A
PERIOD OF YEARS MAY CAUSE DUST DISEA SE OF THE LUNGS.
=======================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:063 HAI-63 ALLOY, NICKEL ALLOYS
CAGE:49076
CAGE:49076
============= Composition/Information on Ingredients =============
Ingred Name:MANGANESE (SARA III)
CAS:7439-96-5
RTECS #:OO9275000
Fraction by Wt: 4%
OSHA PEL:(C) 5 MG/M3 DUST
ACGIH TLV:5 MG/M3 DUST 9293
Ingred Name:NICKEL (SARA III)
CAS:7440-02-0
RTECS #:QR5950000
Fraction by Wt: 95%
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3
Ingred Name:SILICON
CAS:7440-21-3
RTECS #:VW0400000
Fraction by Wt: 1%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:UNDER NORM HNDLG & USE, EXPOS TO
SOLID, MASSIVE FORMS OF ALLOY PRESENTS FEW HLTH HAZ. THEY MAY
INCLUDE SKIN IRRIT/ OTHER ALLERGIC REACTIONS IN SENSITIVE
INDIVIDUALS.ACUTE: EXPOS TO DUST, WELDING FUMES & GASES MAY CAUSE
NAUSEA, TIGHTNESS OFCHEST, FEVER, IRRIT OF EYES, NOSE, THROAT &
SKIN; LOSS OF (EFTS OF OVEREXPOS)
Explanation of Carcinogenicity:NICKEL: ANTICIPATED TO BE A CARCINOGEN:
NTP, GROUP 2B: IARC.
Effects of Overexposure:HLTH HAZ:CONSCIOUSNESS DUE TO WELDING GASES/
LACK OF O2. CHRONIC: ADVERSE EFTS MAY INCLUDE SKIN SENSIT,
NEUROLOGICAL DAM & RESP DISEASES (BRONCHIAL ASTHMA, LUNG
FIBROSIS/PNEUMOCONIOSIS). RECENT EPIDEM IOLOGICAL STUDIES OF
WORKERS MELTING & WORKING ALLOYS CONTAINING NICKEL-CHROMIUM HAVE
FOUND NO INCREASED RISK OF CANCER
Medical Cond Aggravated by Exposure:SKIN IRRITATION OR OTHER ALLERGIC
REACTIONS IN SENSITIVE INDIVIDUALS.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE FROM EXPOSURE & OBTAIN PROMPT MEDICAL
ATTENTION. ADMINISTER OXYGEN IF UNCONSCIOUS. IF NOT BREATHING,
RESUSCITATE IMMEDIATELY. INGEST: CALL MD IMMEDIATELY . EYES:
IMMEDIATELY FLUSH WITH POTABLE WATER FOR A MINIMUM OF 15 MINUTES,
SEEK ASSISTANCE FROM MD . SKIN: FLUSH W/COPIOUS AMOUNTS OF WATER.
CALL MD .
===================== Fire Fighting Measures =====================
Extinguishing Media:USE MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:MATL IS UNFLAMMABLE; HOWEVER, WELDING
ARCS AND SPARKS CAN IGNITE FLAMMABLE LIQUIDS & VAPORS AND
COMBUSTIBLE SOLIDS.
================== Accidental Release Measures ==================
Spill Release Procedures:UNDER NORM HNDLG & USE, MATL IS NOT VOLAT/
DUSTY & DOES NOT PRESENT SPILLAGE & LEAKAGE PROBLEMS. NO PROT REQD,
EXCEPT AVOID PRLNGD/RPTD DIRECT SKIN CONT IF SENSITIVE TO METALS.
CUTTING,(SUPP DATA
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:MATERIAL IN SOLID FORM DOES NOT
REQUIRE SPECIAL PRECAUTIONS IN HANDLING AND STORING.
Other Precautions:USE INDUSTRIAL HYGIENE AIR MONITORING TO ENSURE THAT
THE USE OF THIS MATERIAL DOES NOT CREATE EXPOSURES WHICH EXCEED THE
LEVELS SPECIFIED FOR THE INGREDIENTS LISTED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF SOLID METAL ALLOYS ARE CONVERTED IN MFG
(INCLUDING, GRINDING, HIGH TEMPS CUTTING & WELDING) PROCESSES TO
DUSTS, FUMES, GASES/MISTS & VENT IS NOT ADEQ TO MAINTAIN EXPOS <
LIMITS SPECIFIED, THEN RESP PROT SHLD BE USED. USE ONLY (SUPP
DATA)
Ventilation:IF SOLID METAL ALLOYS ARE CONVERTED TO DUSTS, FUMES/MISTS,
MAINTAIN WORKING ENVIRON < EXPOS LIMITS SPECIFIED (SUPP DATA)
Other Protective Equipment:WHEN CUTTING, GRINDING/WELDING, WEAR FACE
PROT & FLAME RETARDANT CLOTHING.SELECT WELDING LENS SHADE FROM AWS
(SUPP DATA)
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
SPILL PROC: GRINDING/WELDING OPERATIONS, VACUUM RESIDUE INTO SUITABLE
CONTAINERS AND DISPOSE OF I/A/W EPA OR LOCAL REGS. RESP: NIOSH/MSHA
APPROVED RESPIRATORS I/A/W OSHA 29CFR1910.134. VENT: IN INGRED
IENTS BY USE OF ADEQ EXHAUST VENT. OTHER PROT EQUIP: PUBLICATION
F2.2.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:4982F,2750C
Melt/Freeze Pt:M.P/F.P Text:2597F,1425C
Spec Gravity:8.7 (H2O=1)
Solubility in Water:0
Appearance and Odor:GREY METALLIC;ODORLESS.ALLOY PRODS ARE SOLID METALS
SHAPED AS WIRE, ROD/STRIP.
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID ACIDS. CONTACT WITH MINERAL ACIDS WILL RELEASE HYDROGEN - A
READILY COMBUST GAS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:OXIDES OF METALS, CHROMATES, FLUORIDES
& COMPLEX METALLICS. THE GASES MAY INCLUDE CO, OZONE AND NITROGEN
OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF I/A/W FEDERAL, STATE AND LOCAL
REGULATIONS .
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:6852 ANTIQUE WHITE COLOR SHADES LATEX SEMI-GLOSS
CAGE:01PD6
CAGE:01PD6
============= Composition/Information on Ingredients =============
Ingred Name:TITANIUM DIOXIDE, TITANIUM OXIDE (SUSPECTED ANIMAL
CARCINOGEN, IARC GROUP 3)*96-1*
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 10-20%
OSHA PEL:15 MG/CUM
ACGIH TLV:10 MG/CUM (DUST)
Ingred Name:VINYL ACRYLIC RESIN *96-1*
CAS:25067-01-0
Fraction by Wt: 10-20%
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 10-50%
Ingred Name:VINYL ACETATE
CAS:108-05-4
RTECS #:AK0875000
Fraction by Wt: 0.1-1%
Other REC Limits:10 PPM
ACGIH TLV:35 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:CLAY (KAOLIN), ALUMINUM SILICATE *96-1*
CAS:1332-58-7
RTECS #:GF1670500
Fraction by Wt: 5-10%
ACGIH TLV:10 MG/CUM TOTAL DUST
Ingred Name:PROPANOIC ACID, 2-METHYL, MONOESTER
W/2,2,4-TRIMETHYL-1,3-PENTANEDIOL, TEXANOL(ESTER ALCOHOL)
CAS:25265-77-4
RTECS #:UF6000000
Fraction by Wt: 1-5%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: IRRITATION TO RESPIRATORY
TRACT & MUCOUS MEMBRANE, CNS DEPRESSION, ANESTHETIC EFFECT, BLOOD
ABNORMALITIES, KIDNEY DAMAGE, PNEUMONOCONIOSIS. SKIN: SEVERE
IRRITATION, SENSITIZATION, DERMATIT IS, ABSORPTION. EYES:
IRRITATION. INGESTION: CNS DEPRESSION, RESPIRATORY PROBLEMS,
RESPIRATORY/ANESTHETIC EFFECT.(SUPP)
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, DROWSINESS, DIZZINESS,
LIGHTHEADEDNESS, HEADACHE, UNCOORDINATION, GI DISTURBANCES,
COUGHING, SNEEZING, APATHY, NARCOSIS, LOSS OF CONSCIOUSNESS,
BLISTERING, TEARING, REDNESS, NAUSEA, VOMITI NG, DIARRHEA,
ABDOMINAL PAIN, INTOXICATION, RESPIRATORY PROBLEMS.
Medical Cond Aggravated by Exposure:EYE, SKIN & KIDNEY DISORDERS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE & SUPPORT BREATHING.
HAVE TRAINED PERSON GIVE OXYGEN IF NECESSARY. SKIN: FLUSH W/WATER.
THEN WASH THOROUGHLY W/SOAP & WATER. EYES: FLUSH IMMEDIATELY
W/LARGE AM OUNTS OF WATER FOR 15 MINS. OBTAIN MEDICAL ATTENTION IN
ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:DRY CHEMICAL, FOAM, WATER FOG, CO2
Fire Fighting Procedures:WATER MAY BE USED TO COOL & PROTECT EXPOSED
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT/FIRE. VAPORS ARE >AIR & MAY TRAVEL LONG
DISTANCES TO A SOURCE OF IGNITION & FLASHBACK. (SEE SUPP)
================== Accidental Release Measures ==================
Spill Release Procedures:SHUT OFF LEAK & IGNITION SOURCES. VENTILATE &
EVACUATE AREA. USE PROTECTIVE EQUIPMENT. PLACE COLLECTED MATERIAL
IN PROPER CONTAINER. LARGE: DIKE & CONTAIN. PUMP TO STORAGE/SALVAGE
VESSELS. USE ABSORBE NT TO PICK UP EXCESS RESIDUES. (SEE SUPP)
======================Handling and Storage ======================
Handling and Storage Precautions:STORE <100F. KEEP FROM FREEZING &
IGNITION SOURCES. USE ONLY W/ADEQUATE VENTILATION. KEEP CONTAINERS
TIGHTLY CLOSED & UPRIGHT WHEN NOT IN USE.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. GROUND EQUIPMENT WHEN
TRANSFERRING TO PREVENT ACCUMULATION OF STATIC CHARGE. DON'T TAKE
INTERNALLY. AVOID CONTACT W/SKIN, EYES & BREATHING OF VAPORS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHERE REQUIRED, USE ONLY NIOSH/MSHA APPROVED
RESPIRATION IAW/OSHA STANDARDS. IF SPRAYING/ABRADING, USE
APPROPRIATE RESPIRATORY PROTECTION.
Ventilation:PROVIDE DILUTION VENTILATION/LOCAL EXHAUST TO PREVENT
BUILDUP OF VAPORS.
Other Protective Equipment:EYE WASH, SAFETY SHOWER, IMPERVIOUS
CLOTHING, APRON.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:163-477F
VOC Pounds/Gallon:85
Percent Volatiles by Volume:71.94
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS, ACIDS, REDUCING AGENTS, BASES, ALUMINUM, ZINC, METALS,
PEROXIDES, MAGNESIUM, CAUSTICS, SODIUM & POTASSIUM
Stability Condition to Avoid:ELEVATED TEMPS, ULTRAVIOLET LIGHT, SPARKS,
OPEN FLAME, FREEZING
Hazardous Decomposition Products:CO, CO2, ACRID FUMES, OXYGEN,
ALDEHYDES, TOXIC GASES, ACIDS, PROPIONALDEHYDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF INACCORDANCE W/LOCAL, STATE & FEDERAL
REGULATIONS. AVOID DISCHARGE TO NATURAL WATERS.
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
=======================================================
Product ID: RAM GUARD (QTS)
Cage: 0AV13
Proprietary Ind: Y
=======================================================
Preparer Co. when other than Responsible Party Co.
=======================================================
Cage: 0AV13
=======================================================
Contractor Summary
=======================================================
Cage: 70842
Cage: 050Q3
Cage: 0AV13
Cage: 0ZUM2
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: NO
Skin: NO
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: INHAL:NONE KNOWN.SKIN CONTACT/ABSORPTION:DERM POSSIBLE ON
PROL/REP CONTACT.IRRIT EYES,SKIN,NOSE,THROAT.DIZZ,FATIGUE,DROWSINESS.PERSONS
W/PRE-EXISTING SKIN & LUNG DISORDERS MAY BE ADVERSELY AFFECTED IF
IMPROPERLY EXPO.INGEST:ASPIRATION HAZ IF INGESTED.CNS EFFECTS.EYE:IRRIT,LIGHT
IRRIT IF GROSSLY OVEREXPO.CHRONIC EFFECTS: SLIP HAZARD ON NON-POROUS
SURFACES. FOLLOW GOOD CHEMICAL HYGIENE TO AVOID THES E HAZARDS.
Explanation Of Carcinogenicity: PER MSDS:CARCINOGEN SOURCE FOR INGREDIENTS NOT
LISTED IN NTP/IARC/OSHA.
Signs And Symptions Of Overexposure: DERMATITIS, IRRIT
EYE/SKIN/NOSE/THROAT.DIZZINESS,FATIGUE,DROWSINESS.CNS EFFECTS, ASPIRATION
HAZARD, EYE IRRIT.
Medical Cond Aggravated By Exposure: PERSONS W/PRE-EXISTING SKIN & LUNG
DISORDERS MAY BE ADVERSELY AFFECTED IF IMPROPERLY EXPOSED.
First Aid: EYE/SKIN:FLUSH W/PLENTY OF WATER FOR @LEAST 15MINS.GET MED ATTN.WIPE
OFF SKIN WASH W/SOAP/WATAER.SEE DOCTOR IRRIT PERSISTS.INHAL:GET FRESH
AIR.INGEST:DONT INDUCE VOMIT.GET IMMED MED ATTN.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: ISOLATE/VENTILATE AREA.CAUT:SLIP HAZ.WEAR PROPER
PROTECTIVE GEAR.WIPE UP W/RAG/ABSORBENT MATL IF LG SPILL.WASH AREA
W/SOAP/WATER IF STILL SLIPPERY.DISPO OF ABSORBENT PROPERLY.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: CONTAINS LISTED ON SARA TITLE III SEC 313 REF
40CFR372:DIBUTYL PHTHALATE.CONSULT LOCAL, STATE AND FEDERAL REGULATIONS.OFFER
EMTPY CNTNR FOR RECYCLING OR RECONDITIONING OR WRAP & DISPO IN TRASH IF
ALLO WED BY APPLICABLE LAWS.
Handling And Storage Precautions: DO NOT FREEZE.STORE AWAY FROM HEAT/OPEN
FLAME/DIRECT SUNLIGHT.DO NOT CONTAMIN FOOD/WATER/FEEDSTUFFS BY
USE/STORAGE.REPLACE CAP WHEN NOT IN USE.
Other Precautions: FOLLOW LABEL DIRECTIONS CAREFULLY.KEEP AWAY FROM
CHILDREN.AVOID INHAL MIST.AVOID PROLONGED REPEATED CONTACT.DO NOT PUNCTURE
CONTAINER.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: NONE TO BOILING
Autoignition Temp Text: NA
Lower Limits: NA
Upper Limits: NA
Extinguishing Media: CO2,WATERSPRAY,FOAM.
Fire Fighting Procedures: WEAR SCBA IN CHEMICAL FIRES.KEEP CNTNRS COOL. AND
VAPORS DOWN W/WATER SPRAY.DO NOT ALLOW RUNOFF TO ENTER PUBLIC WATERCOURSES.
Unusual Fire/Explosion Hazard: PLASTIC CONTAIENR MAY MELT IF EXPOSURE TO DIRECT
FLAME OCCURS.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NOT USUALLY NECESSARY.
Ventilation: LOCAL EXHAUST NOT NECESSARY-MECHANICAL (GENERAL) IS ADEQUATE.
Other Protective Equipment: NOT USUALLY NECESSARY.IF NEEDED-BOOTS,APRONS,ETC.
Work Hygienic Practices: USE GOOD CHEMICAL HYGIENE WHILE USING THIS OR ANY
OTHER CHEMICAL COMPOUDNS.
Supplemental Safety and Health: FLAMMABILITY AS PER CPSC FLAME-NOT COMBUSTIBLE.
=======================================================
Physical/Chemical Properties
=======================================================
HCC: N1
B.P. Text: 212F,100C
Vapor Pres: 2550 @70F
Vapor Density: N/DETERMIN
Spec Gravity: 0.95
Evaporation Rate & Reference: N/DETERMINED
Solubility in Water: EMULSIFIES
Appearance and Odor: WHITE OPAQUE LIQUID, AMINE-TYPE SCENT
Percent Volatiles by Volume: NA
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: EXTREME HEAT, COLD.
Materials To Avoid: STRONG ACIDS,BASES & OXIDIZERS.NITRATES.
Hazardous Decomposition Products: CARBON MONOXIDE,CARBON DIOXIDE.SULFUR
DIOXIDE,HYDROGEN SULFIDE,NITROUS OXIDES.
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
Transportation Information
=======================================================
Trans ID NO: 6632
Product ID: RAM GUARD (QTS)
Review Date: 07/18/1997
Net Unit Weight: UNKNOWN
Multiple KIT Number: 0
Review IND: Y
Additional Data: PER MSDS:DOT HAZARD CLASSIFICATION/ID #:NOT APPLICABLE
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: ZZZ
DOT Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: ZZZ
IMO Proper Shipping Name: NOT REGULATED FOR THIS MODE OF TRANSPORTATION
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: ZZZ
IATA Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: ZZZ
AFI Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
HAZCOM Label
=======================================================
Product ID: RAM GUARD (QTS)
Cage: 0AV13
Company Name: RAMCO SPECIALITY PRODUCTS
Street: 5956 STATE RD
Zipcode: 93308-3022
Label Required IND: Y
Date Of Label Review: 07/18/1997
Status Code: C
Label Date: 07/18/1997
Origination Code: F
Skin Protection IND: YES
Signal Word: CAUTION
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: INHAL:NONE KNOWN.SKIN CONTACT/ABSORP:DERM POSSIBLE ON
PROL/REP CONTACT.IRRIT EYES,SKIN,NOSE,THROAT.DIZZ,FTG,DROWS.PERSONS
W/PRE-EXISTING SKIN & LUNG DISORDERS MAY BE ADVERSELY AFFECTED IF
IMPROPERLY E XPO.INGEST:ASPIRATION HAZ IF INGESTED.CNS
EFFECTS.EYE:IRRIT,LIGHT IRRIT IF GROSSLY OVEREXPO.DONTT FREEZE.STORE AWAY
FROM HEAT/OPEN FLAME/DIRECT SUNLIGHT.DONT CONTAM FOOD/WATER/FEEDSTUFFS BY
USE/STORAG E.REPLACE CAP WHEN NOT IN USE.1STAID:EYE/SKIN:FLUSH W/PLENTY OF
WATER @LEAST 15MINS.GET MED ATTN.WIPE OFF SKIN WASH W/SOAP/WATER.SEE DR IRRIT
PERSISTS.INHAL:GET FRESH AIR.INGEST:DONT INDUCE VOMIT.GET IMMED MED
ATTN.TARGET ORGANS:EYE/SKIN/CNS.
=======================================================
| 0 | eyes_protection_not_mandatory |
===================== Product Identification =====================
Product ID:TEFLON FLUOROCARBON RESIN FEP, 100
Preparer's Name:W H MARTIN
CAGE:18873
CAGE:18873
============= Composition/Information on Ingredients =============
Ingred Name:FLUORINATED ETHYLENE PROPYLENE COPOLYMER
CAS:25067-11-2
Other REC Limits:10 MG/M3 TDUST (MFR)
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:(ACUTE) INGEST & SKIN: NOT TOXIC. EYE:
MECHANICAL IRRIT. INHAL: WHEN THERMALLY DECOMPOSED BY HEATING ABOVE
260C, OR BY SMOKING TOBACCO OR CIGS CONTAM W/POLYMER DUST, MAY
CAUSE POLYMER FUME FEVER. SYMP ARE FLU-LIKE, W/CHILLS & FEVER,
WHICH MAY NOT OCCUR UNTIL SEV HRS AFTER EXPOS & PASS OFF WITHIN
(SEE EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: 36-48 HRS, EVEN IN ABSENCE OF
TREATMENT. DUPONT REC TREATING POLYMER DUST AS A NUISANCE
PARTICULATE, AND HAS ESTABLISHED AN AEL OF 10 MG/M3 TOTAL DUST, THE
SAME AS THE TLV FOR OTHER NUISANCEPARTICULATES. (CHRONIC) NONE
KNOWN.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:INHAL: IF EXPOSED TO FUMES FROM OVERHEATING OR COMBUSTION,
MOVE TO FRESH AIR. CONSULT MD IF SYMP PERSIST. EYES: FLUSH WITH
PLENTY OF WATER FOR AT LEAST 15 MIN. CONSULT MD IF SYMP PERSIST.
SKIN: IF MOL TEN POLYMER CONTACTS SKIN, COOL RAPIDLYWITH COLD
WATER. DO NOT ATTEMPT TO PEEL POLYMER FROM SKIN. OBTAIN MEDICAL
ATTN FOR THERMAL BURN. INGEST: CALL MD IMMED .
===================== Fire Fighting Measures =====================
Flash Point Method:OC
Flash Point:DOES NOT FLASH
Extinguishing Media:WATER, CO*2, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
TO PROT FROM HF FUMES WHICH REACT W/WATER TO FORM HYDROFLUORIC
ACID. DOES NOT BURN W/O AN (SEE SUPP DATA)
Unusual Fire/Explosion Hazard:TOXIC FLUORINE COMPOUNDS EVOLVED IN FIRE.
HYDROGEN FLUORIDE (HF), CARBONYL FLUORIDE, CO AND LOW MOLECULAR
WEIGHT FLUOROCARBONS.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP TO AVOID SLIPPING HAZARD.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTAMINATION. KEEP CONTAINERS
CLOSED. BEFORE USING, READ TEFLON "SAFETY IN HANDLING AND USE",
BULLETIN E-35824-1.
Other Precautions:AVOID CONTAMINATION OF CIGARETTES OR TOBACCO WITH
POLYMER DUST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR WHEN
TEMPERATURE EXCEEDS 260C OR IF VENTILATION IS INADEQUATE TO
MAINTAIN HF CONC BELOW THE PEL.
Ventilation:USE LOCAL EXHAUST TO COMPLETELY REMOVE VAPORS AND FUMES
LIBERATED DURING HOT PROCESSING FROM THE WORK AREA.
Other Protective Equipment:LONG SLEEVE SHIRT.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
REFUSE FROM A FIRE INVOLVING TEFLON. HAZ DECOMP PRODS: PARTICULATE
MATTER EVOLVED FROM OVERHEATING MAY CAUSE POLYMER FUME FEVER.
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:527F,275C
Spec Gravity:2.1-2.2
Solubility in Water:INSOLUBLE
Appearance and Odor:WHITE TRANSLUCENT PELLETS WITH NO ODOR.
================= Stability and Reactivity Data =================
MOLTEN ALKALI METALS, INTERHALOGEN COMPOUNDS.
Stability Condition to Avoid:TEFLON WILL BURN IN A ATMOSPHERE OF 95%
OXYGEN WHEN AN IGNITION SOURCE IS PRESENT.
Hazardous Decomposition Products:>280C PRODUCT CAN EVOLVE TOXIC GASEOUS
MATLS SUCH AS HF & PERFLUOROOLEFINS. THE OSHA PEL FOR HF IS 3 PPM.
(SUPP DATA)
==================== Disposal Considerations ====================
Waste Disposal Methods:LANDFILL OR INCINERATION IN COMPLIANCE WITH
FEDERAL, STATE, AND LOCAL REGULATIONS. INCINERATION REQUIRES
SCRUBBING OF GASEOUS PRODUCTS TO REMOVE HYDROGEN FLUORIDE.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:SA 824 3262;(GREASE AUTOMOTIVE)
CAGE:34495
CAGE:34495
============= Composition/Information on Ingredients =============
Ingred Name:PETROLEUM HYDROCARBONS
Fraction by Wt: 100%
===================== Hazards Identification =====================
Effects of Overexposure:POSSIBLE SKIN IRRITATION WITH PROLONGED
CONTACT.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH PLENTY OF WATER. CALL DOCTOR IMMEDIATELY.
SKIN CONTACT: WASH WITH SOAP & WATER. IF SWALLOWED, CALL DOCTOR
IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point:315F COC
Extinguishing Media:DRY CHEMICAL, CO*2, FOAM, SAND, EARTH, WATER FOG.
Fire Fighting Procedures:USE A SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:DENSE SMOKE
================== Accidental Release Measures ==================
Spill Release Procedures:TRANSFER BULK OF MATERIAL TO ANOTHER
CONTAINER. ABSORB WITH PROPER ABSORBENTS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL DRY AREA. KEEP
CONTAINERS CLOSED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED WITH NORMAL USE OF PRODUCT
Ventilation:NONE OTHER NORMAL VENTILATION
Other Protective Equipment:FACE SHIELD
Supplemental Safety and Health
ITEM IS TYPE II OF MILITARY SPECIFICATION.
================== Physical/Chemical Properties ==================
HCC:V6
Boiling Pt:B.P. Text:315F/157C
Vapor Pres:UNK
Vapor Density:UNK
Spec Gravity:0.94
Evaporation Rate & Reference:DETERMINED.
Solubility in Water:NEGLIGIBLE
Appearance and Odor:AMBER, SEMI-SOLID, MINERAL OIL ODOR.
Percent Volatiles by Volume:NOT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS:CHROMIC ACID, H*2O*2, BROMINE.
Hazardous Decomposition Products:DENSE SMOKE, CO, CO*2, OTHER UNKNOWN
ORGANIC COMPOUNDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:STORE IN APPROVED STORAGE CONTAINER & SHIP TO AN
APPROVED DISPOSAL AREA.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:B INDEX MATCHING GEL, PART A AT-8955
Kit Part:Y
CAGE:0PWA9
CAGE:4T858
CAGE:0PWA9
CAGE:64959
============= Composition/Information on Ingredients =============
Ingred Name:PROPRIETARY INGREDIENT
Fraction by Wt: 100%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE IRRITATION OF SKIN AND EYES
ON CONTACT.
Explanation of Carcinogenicity:NONE SPECIFIED BY MANUFACTURER.
Effects of Overexposure:SKIN: REDNESS, ITCHING, DISCOMFORT. EYES:
REDNESS, TEARING, DISCOMFORT.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR 15 MINUTES. SEE DOCTOR. SKIN: WASH
EXPOSED AREAS WITH SOAP AND WATER. INHALATION; NONE. INGESTED: CALL
A DOCTOR.
===================== Fire Fighting Measures =====================
Flash Point:>200F,>93C
Extinguishing Media:CARBON DIOXIDE, SAND, FOAM, DRY CHEMICAL (SODIUM
CARBONATE TYPE).
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE GEAR.
Unusual Fire/Explosion Hazard:FIRE MAY PRODUCE IRRITATING AND/OR TOXIC
GASES AND AEROSOLS FROM DECOMPOSITION/COMBUSTION MAY BE PRESENT.
================== Accidental Release Measures ==================
Spill Release Procedures:MOP, SOAK OR WIPE UP WITH AN ABSORBENT
MATERIAL SUCH AS VERMICULITE OR SAND.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE BELOW 95F TO PROLONG SHELF LIFE.
DO NOT STORE NEAR, FOOD, BEVERAGE OR SMOKING MATERIALS.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED.
Ventilation:USE ADEQUATE MECHANICAL VENTILATION.
Other Protective Equipment:NONE NORMALLY REQUIRED.
Work Hygienic Practices:WASH HANDS AFTER USE AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
AVOID CONTACT WITH SKIN, EYES, OR CLOTHES.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:>302F,>150C
Spec Gravity:1.0
Evaporation Rate & Reference:<1 (ETHER=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:CLEAR LIQUID WITH SLIGHT BROWN TINT.
Percent Volatiles by Volume:<2
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG MINERAL ACIDS, AND STRONG ALKALIS.
Stability Condition to Avoid:CONTACT WITH INCOMPATIBLES; COTACT
PRODUCES A FLAMMABLE GAS.
Hazardous Decomposition Products:OXIDES OF SILICON AND CARBON, TRACES
OF INCOMPLETELY BURNED CARBON PRODUCTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:LOW TEMPERATURE SANITIZER W500L
CAGE:9T403
CAGE:73042
CAGE:9T403
============= Composition/Information on Ingredients =============
Ingred Name:HYPOCHLOROUS ACID, SODIUM SALT; (SODIUM HYPOCHLORITE) - 5%
AVAILABLE CHLORINE
CAS:7681-52-9
RTECS #:NH3486300
Fraction by Wt: 5.3%
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE:CORR. CAUSES SEV BURNS/IRRIT. DAM
MAY NOT BE REVERSIBLE. SKIN:CORR. CAUSES SEV IRRIT/BURNS RSLTG IN
REDNESS, PAIN & POSS TISS DAM. INGEST:HARMFUL IF SWALLOWED. MAY
CAUSE NAUS/VOM/BURNS TO MOUTH & ESOPHAGUS. INHAL:CAUSES MOD TO SEV
IRRIT OF NOSE/THROAT/LUNG TISS IF MISTS/SPRAY ARE INHALED.
CHRONIC:NO KNOWN HAZARDS.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:SKIN & RESPIRATORY CONDITIONS.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH IMMED W/PLENTY OF WATER FOR AT LEAST 15 MINS. CALL
MD IMMED. SKIN:FLUSH W/WATER. WASH W/MILD SOAP & WATER AFTER
REMOVING CONTAMD CLTHG. IF IRRIT OR PAIN IS PRESENT, CALL MD.
INGEST:IF SWALLO WED, IMMED DRINK A LGE QTY OF MILK, EGGWHITES OR
GELATION SOLN OR, IF THESE ARE NOT AVAIL, DRINK LGE QTYS OF WATER.
AVOID ALCOHOL. NOTE TO MD:PROBABLE MUCOSAL DAM MAY CONTRAINDICATE
(SUPP DATA)
===================== Fire Fighting Measures =====================
Flash Point:NOT COMBUSTIBLE
Extinguishing Media:WATER & WATER FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:LIQUID DECOMPOSES WHEN HEATED RELEASING
OXYGEN & DEVELOPING PRESSURE IN CONTAINERS.
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN SPILL. MOP UP OR DILUTE W/LARGE
AMOUNTS OF WATER & FLUSH TO A SANITARY SEWER. WASH AFFECTED AREA
W/WATER. LARGE QUANTITIES MAY REQUIRE NEUTRALIZATION OF
HYPOCHLORITE W/SODIUM THIOSULFATE.
Neutralizing Agent:SODIUM THIOSULFATE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY AREA OUT OF
DIRECT SUNLT. STORE IN A VENTILATED AREA. DO NOT STORE W/FOOD. KEEP
FROM FREEZING. USE ONLY I/A/W LABEL DIRECTIONS.
Other Precautions:KEEP CONTAINER CLOSED WHEN MIXING OR WHEN NOT IN USE.
KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED ACIDIC (MIST OR SPRAY)
CARTRIDGE RESPIRATOR .
Ventilation:LOCAL EXHAUST:IN SPRAY AREA OR WHERE FUMES ARE RELEASED.
MECHANICAL (GEN):50-100 CFM TO MAINTAIN TLV.
Other Protective Equipment:CLOTHING TO AVOID SKIN CONTACT. EYE WASH IN
AREA OF USE. SAFETY SHOWER.
Work Hygienic Practices:WASH HANDS & EXPOSED BODY SURF W/SOAP & WATER.
LAUNDER CONTAMD CLOTHING BEFORE REUSE. CLEAN OR REPLACE CONTAMD
FOOTWEAR.
Supplemental Safety and Health
HAZ DECOMP PROD:HYPOCHLORITE TO SALT W/RELEASE OF OXYGEN. FIRST AID
PROC:THE USE OF GASTRIC LAVAGE. INHAL:REMOVE TO FRESH AIR. IF
BREATHING DIFFICULTY CONTINUES, GIVE OXYGEN. GET MD.
================== Physical/Chemical Properties ==================
HCC:B3
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:22.6
Vapor Density:>1
Spec Gravity:1.140
pH:12.0
Evaporation Rate & Reference:1.02 (H*2O=1)
Solubility in Water:100%
Appearance and Odor:PALE, YELLOW LIQUID W/A STRONG CHLORINE ODOR.
Percent Volatiles by Volume:87(WT)
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS, METALS SUCH AS IRON, COPPER, NICKEL, REDUCING AGENTS & AMMONIA.
Stability Condition to Avoid:SUNLIGHT, HIGH TEMPERATURES FROM STEAM
PIPES & HEATERS.
Hazardous Decomposition Products:IF MIXED W/ACIDS, TOXIC OR IRRITATING
CHLORINE FUMES WILL BE RELSD. HIGH TEMPS CAUSE DECOMP OF (SUPP
DATA)
==================== Disposal Considerations ====================
Waste Disposal Methods:PRODUCT OR RINSATE THAT CANNOT BE USED SHOULD BE
DILUTED W/WATER BEFORE DISCHARGE TO A SANITARY SEWER. TOXIC TO
FISH. DO NOT DISCHARGE TO LAKES, STREAMS OR PONDS UNLESS I/A/W
NPDES PERMIT. DISPOSAL MU ST BE I/A/W FEDERAL, STATE & LOCAL REGS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:RPC-016 3,4-DICHLOROBIPHENYL
CAGE:0MU35
CAGE:0MU35
============= Composition/Information on Ingredients =============
Ingred Name:3,4-DICHLOROBIPHENYL
CAS:2974-92-7
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TOXIC; IRRITANT. TOXIC MATERIAL
CAUSING OTHER TOXIC EFFECTS.
Explanation of Carcinogenicity:NONE
======================= First Aid Measures =======================
First Aid:EYES/SKIN: FLUSH W/COPIOUS AMOUNTS OF WATER. INHALATION:
REMOVE TO FRESH AIR. GIVE OXYGEN IF NECESSARY. OBTAIN MEDICAL
ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:CO2, DRY CHEMICAL POWDER/WATER SPRAY.
================== Accidental Release Measures ==================
Spill Release Procedures:LEAKING BOTTLE MAY BE PLACED IN A PLASTIC BAG
& NORMAL DISPOSAL PROCEDURES FOLLOWED. LIQUID SAMPLES MAY BE
ABSORBED ON VERMICULITE/SAND.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP TIGHTLEY CLOSED & STORE IN A
COOL/DRY PLACE.
Other Precautions:THIS MATERIAL SHOULD ONLY BE USED BY THOSE PERSONS
TRAINED IN THE SAFE HANDLING OF HAZARDOUS CHEMICALS. PREVENT
CONTACT W/SKIN, EYES & CLOTHING. ALL CHEMICALS SHOULD BE CONSIDERED
HAZARDOUS, DIRECT PH YSICAL CONTACT SHOULD BE AVOIDED.
============= Exposure Controls/Personal Protection =============
Other Protective Equipment:CHEMICAL RESISTANT LABORATORY COAT &/RUBBER
APRON, USE APPROPRIATE OSHA/MSMA APPROVED SAFETY EQUIPMENT.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:120.2-122F
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
==================== Disposal Considerations ====================
Waste Disposal Methods:BURN IN CHEMICAL INCINERATOR EQUIPPED W/AN
AFTERBURNER & SCRUBBER IAW/FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:SCREEN WASH, 2555
CAGE:DO971
CAGE:DO971
CAGE:76708
============= Composition/Information on Ingredients =============
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 100%
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Effects of Overexposure:SKIN & EYE: PRIMARY IRRIT. INHAL: ANESTHETIC.
(SEE SUPP DATA)
======================= First Aid Measures =======================
First Aid:EYES: IMMED FLUSH W/ WATER FOR 15 MIN, SEE MD. SKIN: WASH W/
SOAP & WATER. REMOVE CONTAMINATED CLOTHES. INHAL: REMOVE FROM
EXPOS. RESTORE BREATH. KEEP WARM & QUIET. CALL MD.
===================== Fire Fighting Measures =====================
Flash Point:80F; 26.7C (TCC)
Lower Limits:1.0
Extinguishing Media:CO:2, DRY CHEMICAL, FOAM, WATER SPRAY MAY BE
INEFFECTIVE
Fire Fighting Procedures:WATER MAY BE USED TO COOL CLOSED CANS, USE FOG
NOZZLES.
Unusual Fire/Explosion Hazard:CLOSED CANS MAY AUTOIGNITE OR EXPLODE
WHEN EXPOS TO EXTREME HEAT. KEEP FROM HEAT, IGNITION SOURCES.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE SOURCES OF IGNITION. AVOID BREATH
VAPORS. VENTILATE AREA. REMOVE SPILL W/ INERT ABSORBENT AND
NON-SPARKING TOOLS.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 120F; 49C. STORE
LARGE QUANTITIES IN BLDGS DESIGNED FLAMMABLE LIQUIDS.
Other Precautions:CONTAINERS SHOULD BE GROUNDED WHEN POURING. AVOID
FREE FALL OF LIQ IN EXCESS OF A FEW INCHES. DO NOT TAKE INTERNALLY.
DO NOT FLAME CUT, BRAZE OR WELD W/O APPRVD RESPIRATOR OR ADEQUATE
VENT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:MFR RECOMNDS NIOSH/MSHA APPRVD RESPIRATOR FOR
PARTICULAR EXPOSURE.
Ventilation:GENERAL DILUTION/LOCAL EXHAUST SUFFICIENT TO KEEP BELOW
TLV.
Other Protective Equipment:PREVENT PROLONGED SKIN CONTACT W/
CONTAMINATED CLOTH.
Supplemental Safety and Health
OVEREXPOSURE: IRRIT OF RESP TRACT OR ACUTE NERVOUS SYS DEPRESN MARKED
BY HDCH,DIZZ,STAGGERING GAIT,CONT-USN,UNCON, OR COMA. CONTAINER
SIZE: NO SIZE INFO AVAILABLE.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:281-284F
Vapor Pres:6.0
Vapor Density:>1
Spec Gravity:0.87
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:INSOLUBLE
Appearance and Odor:CLEAR LIQUID
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:THERMAL: HAZARDOUS FUMES WHICH MAY
CONTAIN CO & OXIDES OF N
==================== Disposal Considerations ====================
Waste Disposal Methods:MFR RECOMMENDS DO NOT INCINERATE CLOSED
CONTAINERS. DISPOSAL METHOD MUST BE IAW FEDERAL, STATE AND LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:EPOXYLITE # 213 PART B
Kit Part:Y
CAGE:11147
CAGE:11147
============= Composition/Information on Ingredients =============
Ingred Name:COAL TAR
CAS:65996-89-6
Fraction by Wt: 71% %
Other REC Limits:NONE RECOMMENDED
Ingred Name:DIETHYLENE TRIAMINE
CAS:111-40-0
RTECS #:IE1225000
Fraction by Wt: 4% %
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1 PPM
ACGIH TLV:S, 1 PPM; 9293
Ingred Name:PROPYLENE GLYCOL MONOMETHYL ETHER
CAS:107-98-2
RTECS #:UB7700000
Fraction by Wt: 4% %
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9293
===================== Hazards Identification =====================
LD50 LC50 Mixture:NOT SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:NO OSHA:NO
Health Hazards Acute and Chronic:TRANSIENT EYE IRRITATION, SKIN
SENSITIZATION
Explanation of Carcinogenicity:REPEATED SKIN EXPOSURE MAY LEAD TO SKIN
CANCER. INHALATION OF VAPORS OVER SEVERAL YEARS MAY PRESENT LUNG
CANCER HAZARD.
Effects of Overexposure:TRANSIENT EYE IRRITATION, NO CORNEAL INJURY
EXPECTED, SKIN IRRITATION/RASHES/HIVES, RESPIRATORY TRACT
IRRITATION UNLIKELY.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN AND EYE DISORDERS
MAY BE AGGRAVATED BY EXPOSURE TO THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR 15 MINUTES. CONSULT A PHYSICIAN.
SKIN: WASH PROMPTLY WITH SOAP AND WATER. INGESTION: SEEK MEDICAL
ATTENTION IMMEDIATELY. INHALATION: REMOVE TO FRESH AIR. SEEK
MEDICAL ATTENT ION IF NEEDED.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:127F,53C
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:FOAM CARBON DIOXIDE, DRY CHEMICAL OR WATER SPRAY
Fire Fighting Procedures:WATER SHOULD BE USED TO KEEP FIRE-EXPOSED
CONTAINERS COOL. IF A LEAK OR SPILL HAS NOT IGNITED, USE WATER
SPRAY TO DISPERSE THE VAPORS AND TO PROTECT FIREFIGHTER
Unusual Fire/Explosion Hazard:DO NOT ENTER CONFINED FIRE SPACE WITHOUT
SELF-CONTAINED BREATHING APPARATUS TO PROTECT FROM FUMES.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB WITH INERT MATERIAL (CLAY, SAND, ETC)
AND PLACE IN APPROPRIATE CONTAINERS WITH NON-SPARKING TOOLS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY PLACE. KEEP AWAY
FROM OPEN FLAMES AND HIHG TEMPERATURES. PRACTICE GOOD CAUTION AND
PERSONAL CLEANLINESS TO AVOID SKIN CONTACT.
Other Precautions:AVOID BREATHING VAPORS OF THIS MATERIAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY NEEDED. USE A NIOSH RESPIRATOR
WITH VAPOR/GAS FILTER FOR PERSONAL COMFORT.
Ventilation:GOOD ROOM VENTILATION USUALLY ADEQUATE FOR MOST OPERATION.
Other Protective Equipment:CLEAN, BODY COVERING CLOTHING
Work Hygienic Practices:WASH WITH SOAP AND WATER AFTER HANDLING PRODUCT
AND BEFORE EATING DRINKING OR SMOKING.
Supplemental Safety and Health
WARNING: THIS CONTAINER HAZARDOUS WHEN EMPTY. SINCE EMPTY CONTAINERS
RETAIN PRODUCT RESIDUES (VAPOR, LIQUID OR SOLIDS) ALL LABELED
HAZARDOUS PRECAUTIONS MUST BE OBSERVED. DO NOT REUSE "EMPTY
CONTAINER S" FOR FOOD, CLOTHING OR PRODUCTS FOR HUMAN OR ANIMAL
CONSUMPTION OR SKIN CONTACT WITHOUT PROFESSIONAL CLEANING.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:248F,120C
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Vapor Pres:NOT GIVEN
Vapor Density:NOT GIVEN
Spec Gravity:1.25
Evaporation Rate & Reference:NOT GIVEN
Solubility in Water:SLIGHT
Appearance and Odor:BLACK LIQUID, COAL TAR SMELL, CHARACTERISTIC AMINE
ODOR
Percent Volatiles by Volume:< 4%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG LEWIS OR MINERAL ACIDS AND CAUSTICS.
Stability Condition to Avoid:EXCESS HEATING OVER LONG PERIODS OF TIME
DEGRADES RESIN.
Hazardous Decomposition Products:CARBON MONOXIDE, ALDEHYDES AND ACIDS
MAY BE FORMED DURING COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT, RESIDUE, DISPOSAL CONTAINER OR
LINER IN ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:VECTRA, 14070-2-3
Preparer's Name:TERRY A MEYERS
CAGE:GO109
CAGE:GO109
CAGE:32204
============= Composition/Information on Ingredients =============
Ingred Name:ETHANOL, 2-(2-ETHOXYETHOXY)-; (DIETHYLENE GLYCOL MONOETHYL
ETHER)
CAS:111-90-0
RTECS #:KK8750000
Fraction by Wt: 1-5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:DIPROPYLENE GLYCOL MONOMETHYL ETHER; (DIPROPYLENE GLYCOL
METHYL ETHER)
CAS:34590-94-8
RTECS #:JM1575000
Fraction by Wt: 1-5%
OSHA PEL:S, 100 PPM
ACGIH TLV:S,100 PPM/150 STEL
Ingred Name:ETHANOL, 2-BUTOXY-, PHOSPHATE (3:1); (2-BUTOXYETHANOL
PHOSPHATE)
CAS:78-51-3
RTECS #:KJ9800000
Fraction by Wt: 1-3%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:STYRENE-ACRYLATE COPOLYMER; (STYRENE/ACRYLIC POLYMERS)
Fraction by Wt: 10-20%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 70-80%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ZINC OXIDE (SARA 313) (CERCLA)
CAS:1314-13-2
RTECS #:ZH4810000
Fraction by Wt: <0.5%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:POTASSIUM HYDROXIDE (CERCLA)
CAS:1310-58-3
RTECS #:TT2100000
Fraction by Wt: <0.2%
OSHA PEL:C 2 MG/M3
ACGIH TLV:C 2 MG/M3
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:AMMONIUM HYDROXIDE (CERCLA)
CAS:1336-21-6
RTECS #:BQ9625000
Fraction by Wt: 1-3%
OSHA PEL:N/K
ACGIH TLV:N/K
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYES:DIRECT CONTACT OF PRODUCT
CAN CAUSE IRRITATION. SKIN:PROLONGED OR REPEATED CONTACT OF PRODUCT
MAY CAUSE IRRITATION.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD IMMEDIATELY . INHAL:REMOVE TO FRESH AIR.
SUPPORT BREATHING (GIVE O*2/ARTF RESP) . EYES:FLUSH WITH WATER FOR
@ LEAST 15 MINUTES. IF IRRIT PERSISTS, SEEK MEDICAL AID. SKIN:WAS H
WITH PLENTY OF WATER. IF IRRIT PERSISTS, SEEK MEDICAL AID.
===================== Fire Fighting Measures =====================
Extinguishing Media:FAOM, CO*2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:NO SPECIAL HAZARDS KNOWN. USE NIOSH/MSHA
APPROVED SCBA & FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NO SPECIAL HAZARDS KNOWN.
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAINS AMMONIA & ZINC. DO NOT LET
SPILLED/LEAKING MATL ENTER WATERCOURSE. DIKE LG SPILLS. ABSORB
W/OIL-DRI OR SIMILAR INERT MATL. SWEEP/SCRAPE UP & CONTAINERIZE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:CAUTION:AVOID CONT W/EYES. IF SUCH
CONT OCCURS, FLUSH IMMED W/WATER FOR 15 MINUTES. IF IRRIT PERSISTS,
SEE DOCTOR. AVOID PRLNGD CONT W/SKIN.
Other Precautions:KEEP FROM FREEZING. KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NO SPECIAL REQUIREMENTS UNDER NORMAL USE
CONDITIONS. NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE
OF CONCERN .
Ventilation:GENERAL ROOM VENTILATION ADEQUATE.
Other Protective Equipment:USE GOOD PERSONAL HYGIENE PRACTICES.
Work Hygienic Practices:WASH THORO AFTER HANDLING.
Supplemental Safety and Health
PH:8.5-8.9.
================== Physical/Chemical Properties ==================
Spec Gravity:1.0 (H*2O =1)
pH:SUPDAT
Evaporation Rate & Reference:NOT KNOWN
Solubility in Water:COMPLETE
Appearance and Odor:MILKY EMULSION IWTH AMMONIA-LIKE ODOR
Percent Volatiles by Volume:81
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:WHEN EXPOSED TO FIRE, PRODUCES NORMAL
PRODUCTS OF COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:NO SPECIAL METHOD. OBSERVE ALL APPLICABLE
FEDERAL/STATE REGULATIONS AND LOCAL ORDINANCES REGARDING DISPOSAL
OF NON-HAZARDOUS MATERIALS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:L.O.C. REGULAR MULTI-PURPOSE CLEANER
CAGE:69375
CAGE:69375
============= Composition/Information on Ingredients =============
Ingred Name:ALCOHOL ETHOXYLATES; (DETERGENT RANGE ALCOHOL EHTOXYLATE
C12-15 ETHOXYLATED ALCOHOLS)
CAS:68131-39-5
Fraction by Wt: <25%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:COCOAMINE; (COCAMIDE DEA AMIDES, COCO)
CAS:61789-19-3
Fraction by Wt: <10%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPDAT:A HOSPITAL EMERGENCY ROOM.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC:SKIN CONTACT AND MINIMIZE INHALATION EXPOSURE
ARE RECOMMENDED.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN:PRODUCT IS NOT PRIMARY IRRITANT.
PROLONGED OR REPEATED CONTACT WITH PRODUCT MAY CAUSE DRY SKIN.
EYE:PRODUCT IS PRIMARY IRRITANT. INGEST:MAY CAUSE IRRITATION OF
MOUTH AND THROAT, UPSET STOMACH, NA USEA, VOMITING AND DIARRHEA.
INHALATION:MAY CAUSE IRRITATION OF NOSE, THROAT AND LUNGS.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN, EYE AND
RESPIRATORY DISORDERS.
======================= First Aid Measures =======================
First Aid:SKIN:RINSE THORO W/WATER. EYE:REMOVE CONT LENSES. RINSE
W/GENTLY STREAMS OF LUKEWARM WATER FOR @ LST 15 MIN, HOLDING
EYELIDS OPEN. IF IRRIT DEVELOPS, GET MED ADVICE BY CALLING EMER
INGEST:IF VICTIM IS A CHILD, GIVE 4-8 OZS OF WATER. FOR ADULTS,
GIVE 8-12 OZS OF WATER. DO NOT INDUCE VOMIT WHEN PROD IS SWALLOWED.
IF VOMIT OCCURS (SUPDAT)
===================== Fire Fighting Measures =====================
Flash Point:NONFLAM/COMBUST
Extinguishing Media:USE WATER SPRAY, FOAM, DRY CHEMICAL, CO*2.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . COOL CONTAINERS WITH WATER.
Unusual Fire/Explosion Hazard:NO EXPLOSION HAZS IDENTIFIED. PRODS OF
COMBUSTION:CO, CO*2, NO*2, COCL*2, HCL, SMOKE, SOOT, UNIDENTIFIED
ORGANICS.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE POTENTIAL IGNITION SOURCES. WEAR
APPROP PERSONAL PROTECTION EQUIPMENT (NIOSH/MSHA APPROVED
CLOTHING). CONTAIN/DIKE SPILL TO P REVENT ENVIRONMENTAL RELEASE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:PROD IS CONSUMER PROD PACKAGED IN BOTH
CONSUMER AS WELL AS LARGER SIZES.
Other Precautions:TO EXTENT PROD IS USED IN FASHION TYPICAL TO THAT OF
CONSUMER, PROT MEASURES ARE NOT NORMALLY NEC. WHERE USE CNDTNS &/OR
EXTENT & DURATION OF EXPOS DIFFER FROM TYPICAL CONSUMER USE,
HOWEVER, APPROP PR OT MEAUSRES TO PVNT EYE & PRLNGD(ING 4)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATORY PROTECTION
APPROPRIATE FOR THE HAZARD PRESENTED.
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:EMERGENCY EYE WASH & DELUGE SHOWER WHICH
MEET ANSI DESIGN CRITERIA . PROTECTIVE CLOTHING.
Work Hygienic Practices:FOR GOOD PERSONAL HYGIENE, INSURE PROMPT
REMOVAL FROM SKIN AND CLOTHING.
Supplemental Safety and Health
PH:9.5-10.5 (AS IS). FIRST AID PROC:SPONTANEOUSLY, KEEP VICTIM IN AN
MSDS/LOC/REGIONAL POIS CTL CTR/HOSPITAL EMER ROOM. INHAL:REMOVE TO
FRES H AIR. IF IRRIT/BRTHG DFCLTY DEVELOPS, GET MED ADVICE BY
================== Physical/Chemical Properties ==================
Spec Gravity:1-1.02 (H*2O=1)
pH:SUPDAT
Appearance and Odor:THIS PROD IS CLEAR, LIGHT YELLOW LIQUID WITH A MILD
DETERGENT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS, STRONG OXIDIZERS.
Stability Condition to Avoid:AVOID EXCESSIVE HEAT, FLAME, CONTACT WITH
ACIDS, STRONG OXIDIZERS.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:THIS PRODUCT IS A U.S. EPA RCRA HAZARDOUS WASTE.
DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
=======================================================
Product ID: HYDROLASTIC FINISH COATING (078 LINE) 078193
Cage: 85519
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 85519
Box: 600
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: INHALATION: IRRITATION OF RESPIRATORY TRACT. PROLONGED
INHALATION MAY LEAD TO MUCOUS MEMBRANE IRRITATION, DROWSINESS AND/OR
LIGHT-HEADEDNESS, HEADACHE, NAUSEA. SKIN CONTACT: IRRITATION OF SKIN. PROLON
GED OR REPEATED CONTACT CAN CAUSE DERMATITIS. EYE CONTACT: IRRITATION OF
EYES. PROLONGED OR REPEATED (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: HLTH HAZ: CONTACT CAN CREATE BLURRED
VISION, CORNEAL INJURY. INGESTION: AMOUNTS INGESTED INCIDENTAL TO CONSUMER
AND INDUSTRIAL HANDLING ARE NOT LIKELY TO CAUSE INJURY; INGESTION OF LARGER
AMOUNTS COUL D CAUSE SERIOUS INJURY.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: INHAL: REMOVE TO FRESH AIR. RESTORE & SUPPORT CONTINUED BRTHG.
HAVE TRAINED PERSON GIVE OXYGEN IF NEC. GET EMER MED ATTN. SKIN: WASH OFF
QUICKLY W/PLENTY OF WATER, THEN SOAP & WATER; REMOVE CONTAMD CL THG. WASH
CONTAMD CLTHG BEFORE REUSE. EYES: FLUSH IMMED W/LG AMTS OF WATER, ESP UNDER
LIDS, FOR AT LEAST 15 MIN. OBTAIN EMER MED TREATMENT. INGEST: IF SWALLOWED,
OBTAIN MED TREATMENT IMMED.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: COLLECT IN CONTAINER FOR DISPOSAL, ACCORDING TO
HEALTH AND ENVIRONMENTAL REGULATIONS. CLEAN UP WITH WATER BEFORE ALLOWING TO
DRY.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS.
Handling And Storage Precautions: STORE BELOW 100F. KEEP FROM FREEZING.
Other Precautions: DO NOT TAKE INTERNALLY. KEEP OUT OF REACH OF CHILDREN.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: NON FLAMMABLE
Lower Limits: SEE INGS
Extinguishing Media: DRY CHEMICAL OR FOAM.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA AND FULL PROTECTIVE EQUIPMENT
(FP N). NON-FLAMMABLE. WATER MAY BE USED TO COOL AND PROTECT EXPOSED
CONTAINERS.
Unusual Fire/Explosion Hazard: CLOSED CONTAINERS MAY BURST IF EXPOSED TO
EXTREME HEAT OR FIRE.
=======================================================
Control Measures
=======================================================
Respiratory Protection: CONTROL ENVIRONMENTAL CONCENTRATIONS BELOW APPLICABLE
STANDARDS. WHERE RESPIRATORY PROTECTION IS REQUIED, USE ONLY NIOSH APPROVED
RESPIRATORS IN ACCORDANCE WITH OSHA STANDARD 29 CFR 1910.134.
Ventilation: MAINTAIN ADEQUATE VENTILATION TO ENSURE AIR ENTRY DURING
APPLICATION AND DRYING TO PREVENT BUILD-UP OF VAPORS.
Other Protective Equipment: ANSI APPROVED EYE WASH & DELUGE SHOWER (FP N). SKIN
CREAM (IF NEEDED).
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: USERS OF "L" VERSION SHOULD CONSULT "LR"
VERSION FOR ADDITIONAL INFORMATION (FP N).
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: >212F,>100C
Vapor Pres: SEE INGS
Spec Gravity: 1.05-1.27 (FPN)
Evaporation Rate & Reference: SLOWER THAN ETHYL ETHER
Appearance and Odor: NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume: 62-70
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: ELEVATED TEMPERATURES. CONTACT WITH OXIDIZING
AGENTS.
Materials To Avoid: OXIDIZERS, ACIDS, BASES, AMINES.
Hazardous Decomposition Products: IF INVOLVED IN FIRE (FROM OTHER SOURCES)
COULD CONCEIVABLY RESULT IN RELEASE OF CARBON DIOXIDE AND CARBON MONOXIDE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: HYDROLASTIC FINISH COATING (078 LINE) 078193
Cage: 85519
Company Name: M A BRUDER & SONS INC
Street: 600 REED RD
PO Box: 600
Zipcode: 19008
Label Required IND: Y
Date Of Label Review: 10/15/1996
Status Code: C
Label Date: 10/15/1996
Origination Code: G
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Severe
Contact Hazard: Moderate
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE: INHALATION: IRRITATION OF RESPIRATORY TRACT.
PROLONGED INHALATION MAY LEAD TO MUCOUS MEMBRANE IRRITATION, DROWSINESS
AND/OR LIGHT-HEADEDNESS, HEADACHE, NAUSEA. SKIN CONTACT: IRRITATION OF SKIN.
PROLONGED OR REPEATED CONTACT CAN CAUSE DERMATITIS. EYE CONTACT: IRRITATION
OF EYES. PROLONGED OR REPEATED CONTACT CAN CREATE BLURRED VISION, CORNEAL
INJURY. INGESTION: LARGE AMOUNTS COULD CAUSE SERI OUS INJURY. CHRONIC: NONE
LISTED BY MANUFACTURER.
=======================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:NEOSIL A
Kit Part:Y
CAGE:8Z212
CAGE:8Z212
============= Composition/Information on Ingredients =============
Ingred Name:CRYSTALLINE-FUSED SILICA, SILICON DIOXIDE, AMORPHOUS QUARTZ
(SUSPECTED HUMAN CARCINOGEN BY IARC - GROUP 2A) *96-1*
CAS:60676-86-0
RTECS #:VV7328000
OSHA PEL:10 MG/CUM RESP SIO2
ACGIH TLV:0.1 MG/CUM RESP DUST
Ingred Name:POLYORGANOSILOXANE POLYMERS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INJURY TO HEATLH IF SWALLOWED.
Explanation of Carcinogenicity:SEE INGREDIENTS.
Effects of Overexposure:INJURY TO HEALTH IF SWALLOWED.
======================= First Aid Measures =======================
First Aid:EYES: WASH W/WATER FOR 15 MINS. SKIN: WASH W/SOAP & WATER.
INGESTION: LET VICTIM VOMIT. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:>392F
Lower Limits:4
Upper Limits:74
Extinguishing Media:CO2, FOAM, WATERFOG (POWDER NOT PRACTICAL)
================== Accidental Release Measures ==================
Spill Release Procedures:VULCANIZED MATERIAL CAN BE DISPOSED OF IN A
SPECIAL INSTALLATION.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED IN A DRY & COOL
ROOM.
Other Precautions:AVOID CONTACT W/SKIN & EYES.
============= Exposure Controls/Personal Protection =============
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Vapor Pres:>0.1
Spec Gravity:1.05
Solubility in Water:INSOLUBLE
Appearance and Odor:CLEAR LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALKALIS
Stability Condition to Avoid:TEMPS >140F, ROOM TEMP
Hazardous Decomposition Products:CO: >572F, FORMALDEHYDE: >572F,
METHANE: >392F.
Conditions to Avoid Polymerization:TEMPS >392F, ROOM TEMP.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:MIL-L-2104,LUBR. OIL,INT. COMB ENG.,GR 40
CAGE:DO992
CAGE:5H505
CAGE:DO992
============= Composition/Information on Ingredients =============
Ingred Name:PETROLEUM HYDROCARBONS
ACGIH TLV:UNK
===================== Hazards Identification =====================
Effects of Overexposure:DERMATITIS IN SENSITIVE INDIVIDUALS AFTER
EXTENDED EXPOSURE.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/WATER;CALL DR.SKIN:WASH W/SOAP &
WATER.INHAL:N/A.INGEST:CALL DR.
===================== Fire Fighting Measures =====================
Flash Point:435F COC
Extinguishing Media:DRY CHEMICAL,CO*2,WATER SPRAY
Fire Fighting Procedures:STANDARD PETROLEUM PROCEDURES.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE WITH ABSORBENT MATERIAL SUCH AS
SAND,CLAY,ETC;REMOVE FROM WATER BY SKIMMING.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CLEAN & DRY.PROTECT CONTAINERS
FROM PHYSICAL DAMAGE.WEAR SELF-CONTAINED BREATHING
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SELF-CONTAINED BREATHING APPARATUS IF REQUIRED
Ventilation:NONE
Other Protective Equipment:NONE
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:V6
Vapor Pres:0.0
Spec Gravity:0.9176
Appearance and Odor:OILY LIQUID,NO OBJECTIONABLE ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT W/STRONG OXIDIZING AGENTS,CORROSIVES.
Hazardous Decomposition Products:VARIOUS HYDROCARBONS
==================== Disposal Considerations ====================
Waste Disposal Methods:ABSORPTION,CONTROLLED BURNING.OBSERVE
LOCAL,STATE & FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:WAKEFIELD W-120,P/N100075,THERMAL (SEE SUP)
Preparer's Name:DAVID F HEGARTY
CAGE:05820
CAGE:05820
============= Composition/Information on Ingredients =============
Ingred Name:ZINC OXIDE
CAS:1314-13-2
RTECS #:ZH4810000
Fraction by Wt: 60-80%
Other REC Limits:N/K
OSHA PEL:15MG/M3 TDUST/5 FUME
ACGIH TLV:10MG/M3 TDUST; 9293
Ingred Name:SILICONE RESIN
CAS:63148-62-9
Fraction by Wt: 20-40%
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:N/K
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:HARMFUL IF SWALLOWED.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES:SLIGHT IRRIT (DIRECT
CONTACT).SKIN:POSSIBLE IRRIT/ABSORPTION.INGESTION:HARMFUL IF
SWALLOWED.INHALATION:INHALATION OF VAPORS AT ELEVATED TEMPERATURES
MAY CAUSE IRRIT.EXPOSURE TO FILLER MATERIAL UN LIKELY UNLESS
APPLICATION RESULTS IN GENERATION OF MISTS/FUMES OR MACHINING OF
CURED PRODUCT GENERATES DUST PARTICLES.
Medical Cond Aggravated by Exposure:NO DATA AVAILABLE FOR THIS PRODUCT
MIXTURE.
======================= First Aid Measures =======================
First Aid:GET MEDICAL ATTENTION IF SYMPTOMS PERSIST.EYES:FLUSH WITH
WATER FOR 15 MINUTES-GET MEDICAL ATTENTION IF IRRITATION
PERSISTS.SKIN:REMOVE CONTAMINATED CLOTHING.WASH SKIN WITH
WATER.INGESTION:DILUTE WITH WATER.GET IMMEDIATE MEDICAL
ATTENTION.INHALATION:REMOVE TO FRESH AIR.GIVE OXYGEN IF BREATHING
DIFFICULT;GIVE ARTIFICIAL RESPIRATION IF NOT BREATHING;GET
IMMEDIATE MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:SEE SUPP DATA
Extinguishing Media:USE CARBON DIOXIDE, FOAM, DRY CHEMICAL, OR WATER
FOG.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD WEAR SELF-CONTAINED
BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:TOXIC VAPORS MAY BE EVOLVED UPON EXPOSURE
TO HEAT OR OPEN FLAME.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL:WIPE UP OR ABSORB WITH
VERMICULITE,ETC.SCRUB AREA W/ SOAPY WATER & RINSE.PREVENT RINSE
FROM ENTERING DRAINS/OTHER WATERWAYS.CLASSIFY SPILL/RINSE AS
CHEMICAL WASTE.LARGE:SCRAPE OR SHOVEL ABSORBED WASTE & ABSORBENT
INTO CONTRS.FOLLOW-UP AS ABOVE.
Neutralizing Agent:N/K
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY PLACE.KEEP REMOVED
FROM ANY HEAT OR OPEN FLAME.PREVENT CONTACT WITH SKIN,EYES OR
CLOTHING.DO NOT INGEST OR SWALLOW THIS MATERIAL.
Other Precautions:N/K
============= Exposure Controls/Personal Protection =============
Respiratory Protection:N/K
Ventilation:CONSULT LOCAL SAFETY/HEALTH AUTHORITIES IF ADDITIONAL
GUIDANCE IS NEEDED .
Other Protective Equipment:PROPER PROTECTIVE CLOTHING TO PREVENT
EXPOSURE.
Work Hygienic Practices:REMOVE CONTAMINATED CLOTHING AND WASH BEFORE
REUSING.
Supplemental Safety and Health
PART NO:JOINT COMPOUND.VAPOR PRESSURE:<1 MMHG AT 25C,77F.% VOLATILES BY
WT:NEGLIGIBLE.FLASH POINT:NOT ESTABLISHED;>250F,121C BASED ON FLASH
POINTS OF COMPONENTS.ROUTES OF ENTRY:INHALATION/INGESTION (F P A).
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:N/K
Decomp Temp:Decomp Text:N/K
Vapor Pres:SEE SUPP
Vapor Density:>1 (AIR=1)
Spec Gravity:2.20 (WATER=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:WHITE PASTE.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.AVOID UNCONTROLLED MIXING WITH OR EXPOSURE TO
INCOMPATIBLE SUBSTANCES.
Stability Condition to Avoid:EXPOSURE TO HEAT/OPEN FLAME.
Hazardous Decomposition Products:CARBON MONOXIDE,CARBON DIOXIDE,SILICON
DIOXIDE,ZINC OXIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IAW FEDERAL,STATE,& LOCAL
REGULATIONS.COORDINATION WITH SUPPORTING INSTALLATION/MACOM
ENVIRONMENTAL COORDINATION PRIOR TO DISPOSAL IS RECOMMENDED TO
DETERMINE APPROPRIATE DISPOSAL MET HODS .CLASSIFY AS CHEMICAL
WASTE.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:GLID-THANE ONE POLYURETHANE COATING 6100 SERIES, 6122
CAGE:72818
CAGE:72818
============= Composition/Information on Ingredients =============
Ingred Name:ING 5: CONDITIONS MAY LEAD TO UNCONSCIOUSNESS, RESPIRATORY
FAILURE, ASPHYXIATION, AND EVEN DEATH.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC: EQUIPMENT WHEN TRANSFERRING TO PREVENT
ACCUMULATION OF STATIC CHARGE.
RTECS #:9999999ZZ
Ingred Name:DISTILLATES RESIN, LOW BOILING; (AROMATIC PETROLEUM
DISTILLATES). VP: 10 @ 68F. LEL: 0.9%
CAS:68477-31-6
RTECS #:JN9500000
Fraction by Wt: 47-52%
Ingred Name:AROMATIC PETROLEUM DISTILLATES. VP: 1 @ 68F. LEL: 0.9%
CAS:68188-48-7
Fraction by Wt: 47-52%
Ingred Name:SUPP DATA: TO SOLVS W/PERM BRAIN & NERV SYS DMG.
INTENTIONAL MISUSE BY DELIBERATELY CONC & INHALING THE CONTENTS
(ING 4)
RTECS #:9999999ZZ
Ingred Name:ING 3:MAY BE HARMFUL/FATAL. SUPP HLTH INFO: EXPOSURE TO
MATLS IN THIS PROD HAVE BEEN ASSOC W/POSS CARDIAC (ING 5)
RTECS #:9999999ZZ
Ingred Name:ING 4:ABNORMALITIES, BLOOD ABNORMALITIES, LIVER DMG, KIDNEY
DMG. EXCESS INHAL OF SOLV VAPS UNDER UNCONTROLLED (ING 6)
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL:IRRIT OF RESP TRACT. PRLNGD
INHAL MAY LEAD TO MUC MEMB IRRIT, FATIGUE, DROWSINESS, DIZZINESS
&/OR LIGHTHEADEDNESS, HDCH, UNCOORD, NAUS, VOMIT, COUGHING, MENTAL
APATHY, CNS DEPRESS, RESP PROBLEMS , INTOXICATION CONFUSION,
ANESTHETIC EFT/NARCOSIS, DFCLTY OF BRTHG, ALLERGIC RESPONSE, POSS
SENSIT (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:OF RESP TRACT. SKIN:IRRIT, PRLNGD/RPTD
CNTCT CAN CAUSE DERM, DEFAT, ALLERGIC RESPONSE. POSS SENSIT.
EYE:IRRIT.PRLNGD/RPTD CNTCT CAN CAUSE BLURRED VISION, TEARING,
REDNESS,(SUPP DATA)
Medical Cond Aggravated by Exposure:INGS CNTND IN PROD HAVE BEEN
REPORTED TO AGGRAVATE PREEXISTING EYE, SKIN, RESP DISORDERS, LUNG
DISORDERS, ASTHMA-LIKE CNDTNS, BLOOD DISORDERS, KIDNEY DISORDERS,
LIVER DISORDERS, NERV SYS DISORDERS.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. RESTORE & SUPPORT CONTINUED BRTHG.
GET EMER MED ATTN. HAVE TRAINED PERSON GIVE O*2 IF NEC. GET MED
HELP FOR ANY BRTHG DFCLTY. SKIN/EYE:WASH OFF QUICKLY W/PLENTY OF
WATER FOR AT LEAST 15 MIN, THEN SOAP AND WATER; REMOVE CONTAM
CLTHG. WASH CONTAM CLTHG BEFORE REUSE. INGEST: IF SWALLOWED, OBTAIN
MED TREATMENT IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point:126F,52C
Lower Limits:0.9%
Extinguishing Media:DRY CHEMICAL OR FOAM.
Fire Fighting Procedures:WATER MAY BE USED TO COOL UNRUPTURED
CONTAINERS TO PREVENT PRESSURE BUILD-UP. WEAR NIOSH/MSHA APPROVED
SCBA AND FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:CLSD CNTNRS MAY EXPLO WHEN EXPOSED TO
EXTREME HEAT/FIRE. VAPS CAN FORM EXPLO MIX IN AIR AT ELEVATED
TEMPS. MAY DECOMP UNDER FIRE CNDTNS EMITTING (SUPP DATA)
================== Accidental Release Measures ==================
Spill Release Procedures:COMPLY W/ALL APPLICABLE HEALTH & ENVIRONMENTAL
REGS. ELIMINATE ALL SOURCES OF IGNITION. VENT AREA WITH EXPLOSION
PROOF EQUIPMENT. SPILLS MAY BE COLLECTED WITH NON-COMBUSTIBLE
ABSORBENT MATERIALS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE BELOW 100F. KEEP AWAY FROM HEAT,
SPARKS, AND OPEN FLAME. USE ONLY W/ADEQ VENT. DO NOT TAKE
INTERNALLY. KEEP OUT OF REACH OF CHILDREN.
Other Precautions:AVOID CONTACT W/SKIN & EYES, & BRTHG OF VAPS. KEEP
CNTNRS TIGHTLY CLSD & UPRIGHT WHEN NOT IN USE. EMPTY CNTNRS MAY
CONTAIN HAZ RESIDUES. IF SANDING IS DONE, WEAR NIOSH/MSHA APPRVD
DUST MASK TO AVOID B RTHG OF SANDING DUST. GROUND (ING 7)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:CONTROL ENVIRONMENTAL CONCS BELOW APPLICABLE
STANDARDS. WHERE RESP PROT IS REQUIRED, USE ONLY NIOSH/MSHA
APPROVED RESPIRATORS IN ACCORDANCE WITH OSHA STANDARD 29 CFR
1910.134.
Ventilation:PROVIDE DILUTION VENTILATION OR LOCAL EXHAUST TO PREVENT
BUILD-UP OF VAPORS.
Other Protective Equipment:SAFETY SHOWER, EYE WASH.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING, ESPECIALLY
BEFORE EATING OR SMOKING.
Supplemental Safety and Health
EXPLO HAZ: IRRIT AND/OR TOXIC GASES. EFTS OF OVEREXP: SEVERE EYE IRRIT.
INGEST: AMTS INGESTED INCIDENTAL TO CONSUMER & INDUST HNDLG ARE NOT
LIKELY TO CAUSE INJURY; HOWEVER, INGEST OF LRG AMTS AY CAUSE LUNG
INFLAMM & DMG DUE TO ASPIR OF MATL INTO LUNGS. NOTICE: REPORTS HAVE
ASSOC RPTD & PRLNGD OCCUP OVEREXP (ING 3)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>311F,>155C
Vapor Pres:SEE INGS
Spec Gravity:0.875
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS, ACIDS, BASES, AMINES, HYDROXYL CNTNG CMPNDS, ACTIVE HYDROGEN
CMPNDS, REDUCING AGENTS, HALOGENS.
Stability Condition to Avoid:ELEVATED TEMPERATURES. CONTACT WITH
OXIDIZING AGENTS.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH ALL APPLICABLE
REGULATIONS. AVOID DISCHARGE TO NATURAL WATERS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:SOLUTION 41
CAGE:2P860
CAGE:2P860
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM HYDROXIDE (SARA III)
CAS:1310-73-2
RTECS #:WB4900000
OSHA PEL:2 MG/M3
ACGIH TLV:C 2 MG/M3; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:WATER; (WATER SOLUTION)
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 4%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:NITROPHENYLAZO RESORCINOL
Fraction by Wt: <0.1%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:HARMFUL IF SWALLOWED, INHALED OR
ABSORBED THROUGH SKIN. MATERIAL IS EXTREMELY DESTRUCTIVE TO TISSUE
OF MUCOUS MEMBRANES & UPPER RESPIRATORY TRACT, EYES & SKIN. CAUSES
SEVERE BURNS.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD IMMEDIATELY . INHAL:REMOVE TO FRESH AIR.
SUPPORT BREATHING (GIVE O*2/ARTF RESP) . EYES:IMMEDIATELY FLUSH
W/COPIOUS AMOUNTS OF WATER FOR AT LEAST 15 MINUTES. ASSURE ADEQUATE
FLUSHING BY SEPARATING EYELIDS W/FINGERS. SKIN:IMMEDIATELY FLUSH
W/COPIOUS AMOUNTS OF WATER FOR AT LEAST 15 MINUTES.
===================== Fire Fighting Measures =====================
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NON-FLAMMABLE.
================== Accidental Release Measures ==================
Spill Release Procedures:WIPE UP W/PAPER TOWEL & WATER, WEARING
WHILE RUNNING WATER TO DILUTE IT. AVOID SPLATTERING.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTACT W/SKIN & EYES.
Other Precautions:THE HAZARDS & PRECAUTIONS GIVEN HERE APPLY TO ONE
OUNCE, 30 ML SIZE SUPPLIED BY KOSLOW. LARGER AMOUNT OR HIGHER
CONCENTRATIONS MAY HAVE A HIGHER RISK.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:EMERGENCY EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:230F,110C
Spec Gravity:1.5
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG ACIDS, ORGANIC MATERIALS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS .
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:GASOLINE, UNLEADED (ALL GRADES)
CAGE:72190
CAGE:29700
CAGE:72190
============= Composition/Information on Ingredients =============
Ingred Name:NAPHTHA (PETROLEUM), LIGHT CATALYTIC CRACKED
CAS:64741-55-5
Other REC Limits:NONE RECOMMENDED
Ingred Name:NAPHTHA (PETROLEUM), HEAVY CATALYTIC CRACKED
CAS:64741-54-4
Other REC Limits:NONE RECOMMENDED
Ingred Name:NAPHTHA, FULL RANGE REFORMED
CAS:68919-37-9
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT ESTABLISHED.
ACGIH TLV:NOT ESTABLISHED.
Ingred Name:NAPHTHA (PETROLEUM), FULL-RANGE ALKYLATE
CAS:64741-64-6
Other REC Limits:NONE RECOMMENDED
Ingred Name:NAPHTHA (PETROLEUM), SWEETENED
CAS:64741-87-3
Other REC Limits:NONE RECOMMENDED
Ingred Name:BUTANE
CAS:106-97-8
RTECS #:EJ4200000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:800 PPM
ACGIH TLV:800 PPM; 9293
Ingred Name:ADDITIVES
Other REC Limits:NONE RECOMMENDED
Ingred Name:EXXON LISTED THE FOLLOWING CHEMICALS FOR SARA III
REPORTING. THIS PRODUCT MAY CONTAIN THE APPROXIMATE AMOUNTS
INDICATED.
RTECS #:9999999ZZ
Other REC Limits:NONE RECOMMENDED
Ingred Name:BENZENE (SARA III)
CAS:71-43-2
RTECS #:CY1400000
Fraction by Wt: 4.9%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1PPM/5STEL;1910.1028
ACGIH TLV:10 PPM; A2; 9293
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:CUMENE (SARA III)
CAS:98-82-8
RTECS #:GR8575000
Fraction by Wt: 0.3%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 50 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:CYCLOHEXANE (SARA III)
CAS:110-82-7
RTECS #:GU6300000
Fraction by Wt: 0.5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:300 PPM
ACGIH TLV:300 PPM, 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ETHYL BENZENE (SARA III)
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: 2.5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM/125 STEL
ACGIH TLV:100 PPM/125STEL 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:METHYL TERT-BUTYL ETHER (SARA III)
CAS:1634-04-4
RTECS #:KN5250000
Fraction by Wt: 6.0%
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:NAPHTHALENE (SARA III)
CAS:91-20-3
RTECS #:QJ0525000
Fraction by Wt: 0.7%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 PPM/15 STEL
ACGIH TLV:10 PPM/15 STEL; 9293
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 16%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 10%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT) IS >5G/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:INHALATION: MODERATE RISK OF VAPOR
INTOXICATION. MAJOR RISK IS ENCLOSED SPACES WITH POOR VENTILATION.
SKIN: DEFATTING WITH DRYING AND CRACKING CAN LEAD TO DERMATITIS AND
SECONDARY INFECTION. EYE: IRRI TANT. INGESTION: BURNING OF MOUTH
AND UPPER GI TRACT, VOMITING AND DIARRHEA. PROLONGED OR REPEATED
CONTACT: DERMATITIS.
Explanation of Carcinogenicity:CONTAINS B[71-43-2] WHICH IS
LISTED BY NTP AND IARC AND REGULATED BY OSHA AS A CARCINOGEN.
Effects of Overexposure:INHALATION MAY CAUSE EUPHORIA, LUNG IRRITATION
AND EDEMA, HEADACHE, DIZZINESS, DROWSINESS, CONVULSIONS, COMA,
CYANOSIS, GENERALIZED DEPRESSION. INGESTION MAY CAUSE GENERAL
DEPRESSION, SEDATION, RESPIR ATORY DEPRESSION, COMA.
Medical Cond Aggravated by Exposure:MAY AGGRAVATE PRE-EXISTING
DERMATITIS, RESPIRATORY ILLNESS, OR OTHER CONDITIONS WHICH HAVE THE
SAME SYMPTOMS OR EFFECTS AS STATED ABOVE.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH RUNNING WATER FOR 15 MINUTES WHILE HOLDING
EYELIDS OPEN. SKIN: REMOVE CONTAMINATED CLOTHING. WASH SKIN WITH
SOAP AND WATER. INHALATION: REMOVE TO FRESH AIR. FOR RESPIRATORY
DISTRESS, GIVE AIR, OXYGEN, OR CPR IF NECESSARY. INGESTION: DO NOT
INDUCE VOMITING. KEEP HEAD BELOW HIPS IF VOMITING OCCURS TO PREVENT
ASPIRATION INTO LUNGS. GET MEDICAL ATTENTION IF REQUIRED IN ALL
CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:-36F,-38C
Lower Limits:1.4
Upper Limits:7.6
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:WATER MAY BE INEFFECTIVE ON FLAMES, BUT SHOULD
BE USED TO KEEP FIRE-EXPOSED CONTAINERS COOL. LARGE FIRES, SUCH AS
TANK FIRES, SHOULD BE FOUGHT WITH CAUTION.
Unusual Fire/Explosion Hazard:HIGHLY VOLATILE MATERIAL. FLOWING
GASOLINE CAN BE IGNITED BY SELF-GENERATED STATIC ELECTRICITY.
VAPORS MAY TRAVEL ALONG THE GROUND TO A REMOTE IGNITION SOURCE.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL: TAKE UP WITH NON COMBUSTIBLE ABSORBENT
SUCH AS FULLERS EARTH OR SAND. PLACE INTO CONTAINERS FOR LATER
DISPOSAL. LARGE: CONTAIN SPILL IN EARTHEN DIKES FOR LATER RECOVERY.
CONTROL IGNITION SOURCE S AROUND SPILL AREA. REPORT SPILLS AS
REQUIRED.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID STATIC IGNITION HAZARD WHEN
TRANSFERRING MATERIAL. KEEP CONTAINERS CLOSED AND AWAY FROM HEAT &
IGNITION SOURCES! DO NOT USE AS CLEANING AGENT.
Other Precautions:EMPTY CONTAINERS RETAIN SOME LIQUID/VAPOR RESIDUES;
HAZARD PRECAUTIONS MUST BE OBSERVED WHEN HANDLING EMPTIES. KEEP OUT
OF REACH OF CHILDREN! DO NOT USE ANY HYDROCARBON FUEL IN SPACES
WITHOUT ADEQUATE VENTILATION. USE ONLY AS A FUEL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:A NIOSH/MSHA APPROVED ORGANIC VAPOR RESPIRATOR,
SUPPLIED AIR, OR SELF-CONTAINED BREATHING APPARATUS (SCBA) MUST BE
USED WHEN VAPOR CONCENTRATIONS EXCEED THE OCCUPATIONAL EXPOSURE
LIMITS.
Ventilation:USE ADEQUATE VENTILATION TO KEEP VAPOR CONCENTRATIONS OF
THIS MATERIAL BELOW THE OCCUPATIONAL EXPOSURE LIMITS.
Other Protective Equipment:OIL IMPERVIOUS INDUSTRIAL WORK CLOTHING TO
MINIMIZE SKIN CONTACT. EYE BATH AND SAFETY SHOWER RECOMMENDED.
Work Hygienic Practices:USE GOOD PERSONAL HYGIENE. USE WATERLESS HAND
CLEANER TO WASH EXPOSED SKIN. LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
THE VARIABLE COMPOSITION MAKES IT IMPOSSIBLE TO SET A SPECIFIC EXPOSURE
LIMIT FOR ALL COMPOSITIONS OF THIS MATERIAL. SPECIFIC EXPOSURE
LIMITS FOR POTENTIAL COMPONENTS SUCH AS BENZENE SHOULD BE APPLIED
BASED ON AIR MONITORING TO ASSURE EMPLOYEES ARE NOT EXPOSED TO
EXCESSIVE VAPOR LEVELS OF COMPONENTS.
================== Physical/Chemical Properties ==================
HCC:F1
Boiling Pt:B.P. Text:>70F,>21C
Melt/Freeze Pt:M.P/F.P Text:-36F,-38C
Vapor Pres:400
Vapor Density:5
Spec Gravity:0.74
pH:7
Evaporation Rate & Reference:10.5(N-BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR LIQUID WITH GASOLINE ODOR.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES AND OTHER SOURCES
OF IGNITION
Hazardous Decomposition Products:BURNING OR EXCESSIVE HEATING MAY
PRODUCE CARBON MONOXIDE AND OTHER HARMFUL GASES/VAPORS.
==================== Disposal Considerations ====================
Waste Disposal Methods:IT IS THE RESPONSIBILITY OF THE USER TO
DETERMINE IF THE MATERIAL IS A HAZARDOUS WASTE AT THE TIME OF
DISPOSAL. CHECK BEFORE DISPOSING TO BE SURE YOU ARE IN COMPLIANCE
WITH ALL APPLICABLE LAWS AND REG ULATIONS. CHEMTREC/RCRA EMER.
NO.:800-424-9346
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:PC/UA 943-831, ROYAL DEVELOPER 145/145R (13
Preparer's Name:SECURITY & SAFETY DEPT
CAGE:89431
CAGE:89431
============= Composition/Information on Ingredients =============
Ingred Name:CARRIER (CONSISTING OF INGREDIENTS 2-4)
Fraction by Wt: 94-98%
Ingred Name:IRON (EXPOSURE LISTED FOR IRON OXIDE FUME)
CAS:7439-89-6
RTECS #:NO4565500
OSHA PEL:10 MG/M3 (FE)
ACGIH TLV:5 MG/M3 (FE)
Ingred Name:IRON OXIDE
CAS:1317-61-9
OSHA PEL:10 MG/M3 (FE)
ACGIH TLV:5 MG/M3 (FE)
Ingred Name:RESIN
Ingred Name:TONER
Fraction by Wt: 2-6%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:THE PRODUCT HAS BEEN EXTENSIVELY
TESTED AND EVALUATED BY KONICA CORPORATION. WHEN USED AS INTENDED
BY THE CONSUMER IN KINICA COPIERS IT DOES NOT REPRESENT ANY KNOWN
HEALTH OR SAFETY HAZARD.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NONE CURRENTLY DETERMINED.
======================= First Aid Measures =======================
First Aid:INGEST:DILUTE STOMACH WITH SEVERAL GLASSES OF WTAER.
INHAL:MOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTF RESP .
EYE:FLUSH WITH WATER FOR AT LEAST 15 MINUTES. CALL MD. SKIN:WASH
WITH SOAP & WATER.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER, FOAM, CARBON DIOXIDE, OR DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . WHEN IN A MACHING, TREAT AS ELECTIRCAL FIRE
AND DO NOT USE WATER OR FOAM.
Unusual Fire/Explosion Hazard:DEVELOPER IS NOT A COMBUSTIBLE POWDER.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP OR VACUUM.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP FROM CONTACT WITH OXIDIZING
MATERIALS.
Other Precautions:KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED WHEN USED AS INTENDED IN KONICA
COPIERS. NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF
CONCERN .
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:NONE REQUIRED WHEN USED AS INTENDED IN
KONICA COPIERS.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Spec Gravity:7.5 (H*2O=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:GRAYISH, DARK BLUE, DARK GREEN AND DARK RED AND
GRANULAR. ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:STABLE (EXCEPT ABOVE 200C).
Hazardous Decomposition Products:COMBUSTION WILL PRODUCE CO & CO*2.
AVOID BREATHING SMOKE.
==================== Disposal Considerations ====================
Waste Disposal Methods:NO SPECIAL DISPOSAL PROCEDURES REQUIRED. INSURE
CONFORMITY WITH FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:2545 LABOR SAVER MARKING PAINTS
CAGE:08882
CAGE:08882
============= Composition/Information on Ingredients =============
Ingred Name:NO INGREDIENT FOR THIS FORMULATION_INGREDIENT
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: HARMFUL, MAY AFFECT THE
BRAIN & NERVOUS SYSTEM, NOSE & THROAT IRRITATION. SKIN: IRRITTION &
DERMATITIS. EYES: IRRITATION. INGESTION: GI IRRITATION.
REPEATED/PROLONGED OVEREXPOSURE TO SOLVE NTS MAY CAUSE PERMANENT
BRAIN & NERVOUSSYSTEM DAMAGE. XYLENE: EFFECTS THE LIVER & CARDIAC
ABNORMALITIES. (SEE SUPP)
Explanation of Carcinogenicity:NONE
Effects of Overexposure:DIZZINESS, HEADACHE, NAUSEA, STAGGERING GAIT,
CONFUSION, UNCONSCIOUSNESS, COMA, IRRITATION, VOMITING, DIARRHEA,
NARCOSIS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR & RESTORE BREATHING. EYES:
FLUSH W/LARGE AMOUNTS OF WATER FOR 15 MINS. SKIN: WASH W/SOAP &
WATER. INGESTION: ASPIRATION HAZARD. DON'T INDUCE VOMITING. KEEP
WARM & QUIET . OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:<-25F
Extinguishing Media:CO2, DRY CHEMICAL/FOAM.
Fire Fighting Procedures:USE FULL PROTECTIVE EQUIPMENT & SCBA. WATER
SPRAY MAY BE INEFFECTIVE. WATER MAY BE USED TO COOL CLOSED
CONTAINERS. IF WATER IS USED, FOG NOZZLES ARE PREFERRED.
Unusual Fire/Explosion Hazard:EXTREMELY FLAMMABLE. CLOSED CONTAINERS
EXPLODE TO HEAT. DON'T APPLY TO HOT SURFACES. VAPORS ARE > AIR &
TRAVEL ALONG DISTANCE TO SOURCE OF IGNITION/FLASHBACK.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE SOURCES OF IGNITION, VENTILATE AREA &
REMOVE W/INERT ABSORBENT & NON-SPARKING TOOLS.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T STORE >120F. PROTECT FROM
FREEZING. DON'T PUNCTURE/INCINERATE CONTAINERS. KEEP AWAY FROM
HEAT, ELECTRICAL EQUIPMENT, SPARKS & OPEN FLAME.
Other Precautions:INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING &
INHALING THE CONTENTS CAN BE HARMFUL/FATAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED CHEMICAL CARTRIDGE RESPIRATOR
(TC23C) TO REMOVE SOLID AIRBORNE OVERSPRAY PARTICLES ORGANIC VAPORS
DURING SPRAYING & DUSTING/SANDING OF DRY PAINT FILMS. IN CONFINED
AREAS, USE NIOSH APPROVED SUPPLIED AIR RESPIRATORS/HOODS.
Ventilation:GENERAL DILUTION/LOCAL EXHAUST TO KEEP TLV BELOW ACCEPTABLE
LIMITS.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
HLTH HZRD CONT'D: ASPIRATION OF THIS MATERIAL INTO THE LUNGS CAN CAUSE
CHEMIAL PNEUMONITIS WHICH CAN BE FATAL.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:31-284F
Vapor Density:>1
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:85-90
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
INCOMPATIBLE W/STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:OPEN FLAME, HEAT, SPARKS, FREEZING.
Hazardous Decomposition Products:BY OPEN FLAME: CO, CO2 &
UNIDENTIFIABLE CARBON COMPOUNDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS. DON'T INCINERATE CLOSED CONTAINERS.
| 1 | eyes_protection_mandatory |
=======================================================
Product ID: PERMATEX BLUE LABEL CREAM HAND CLEANER
Cage: 08028
=======================================================
Preparer Co. when other than Responsible Party Co.
=======================================================
Cage: 08028
=======================================================
Contractor Summary
=======================================================
Cage: 08028
=======================================================
Ingredients
=======================================================
Cas: 8052-41-3
RTECS #: WJ8925000
% Wt: 40-45
Other REC Limits: 525 MG/CUM
OSHA PEL: 500 PPM
ACGIH TLV: 100 PPM
------------------------------
Cas: 7732-18-5
RTECS #: ZC0110000
% Wt: 35-45
------------------------------
Cas: 61790-45-2
% Wt: 3-8
------------------------------
Cas: 68132-50-3
% Wt: 3-8
------------------------------
Cas: 68154-97-2
% Wt: 3-8
------------------------------
Cas: 64742-65-0
RTECS #: PY8038500
% Wt: 2-6
Other REC Limits: 5 MG/CUM
------------------------------
RTECS #: 9999999VO
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: ORAL LD50(LAB ANIMAL): >5 MG/KG
Route Of Entry Inds - Inhalation: YES
Skin: NO
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: EYE IRRITANT. MAY IRRITATE RESPIRATORY SYSTEM UPON
FREQUENT/PROLONGED USE. HIGH CONCENTRATIONS MAY IRRITATE EYES &
RESPIRATORY SYSTEM. MATERIAL VOMITED AFTER INGESTION & ASPIRATED INTO THE
LUNGS MAY C ASUE BRONCOPNEUMONIA/PULMONARY EDEMA, MAY BE FATAL.
Explanation Of Carcinogenicity: NONE
Signs And Symptions Of Overexposure: IRRITATION, HEADACHE, NAUSEA, DIZZINESS,
WEAKNESS, FATIGUE, UNCONSCIOUSNESS, VOMITING, DIARRHEA, REDNESS &
TEARING.
First Aid: INGESTION: DON'T INDUCE VOMITING. INHALATION: REMOVE TO FRESH AIR.
SKIN: FLUSH W/WATER. EYES: FLUSH THOUROUGHLY W/WATER FOR 15 MINS. OBTAIN
MEDICAL ATTENTION IN ALL CASES.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: RINSE AWAY W/WATER/WIPE UP W/A TOWEL.
Waste Disposal Methods: DISPOSE OF IAW/LOCAL, STATE & FEDERAL REGULATIONS.
RCRA HAZARDOUS WASTE #: D001.
Handling And Storage Precautions: STORE BETWEEN 40F & 100F IN ORDER TO
ENSURE LONG LIFE OF THE EMULSION.
Other Precautions: KEEP AWAY FROM CHILDREN.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: PMCC
Flash Point Text: 124F
Extinguishing Media: CO2 & DRY CHEMICAL POWDER
=======================================================
Control Measures
=======================================================
Ventilation: SUFFICIENT TO MAINTAIN VAPOR CONCENTRATION BELOW TLV.
=======================================================
Physical/Chemical Properties
=======================================================
Spec Gravity: 0.85
PH: 8.6
Solubility in Water: COMPLETE
Appearance and Odor: WHITE CREAM W/PLEASANT SMELL
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: SPARKS, OPEN FLAMES
Hazardous Decomposition Products: ORGANIC VAPORS
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: PERMATEX BLUE LABEL CREAM HAND CLEANER
Cage: 08028
Company Name: LOCTITE CORP AUTOMOTIVE AND CONSUMER GROUP
Street: 4450 CRANWOOD COURT
Zipcode: 44128-4004
Date Of Label Review: 09/12/1994
Status Code: C
Label Date: 09/12/1994
Origination Code: Y
Hazard And Precautions: INOGENS: 2,4-TOLUENE DIISOCYANATE & SILICON
DIOXIDE.
=======================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:HYDROGEN PEROXIDE 35%
Preparer's Name:ED DOHENY/MIKE HOEFLER
CAGE:2P121
CAGE:2P121
============= Composition/Information on Ingredients =============
Ingred Name:HYDROGEN PEROXIDE (SARA III)
CAS:7722-84-1
RTECS #:MX0900000
Fraction by Wt: 35% MIN.
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1 PPM
ACGIH TLV:1 PPM; 9394
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES: "DANGER" OXIDIZER. MAY
CAUSE SEVERE IRRITATION OR BURNS. SKIN: "DANGER" OXIDIZER. MAY
CAUSE SEVERE IRRITATION OR BURNS. INHALATION: HARMFUL IF INHALED.
INGESTION: HARMFUL IF SWALLOWED. CH RONIC: REPEATED EXPOSURE MAY
LEAD TO DRMATITIS WITH DESTRUCTION OF TISSUE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES: IRRITATION, BURNS. SKIN: IRRITATION,
BURNS, DERMATITIS. INHALATION: HARMFUL IF INHALED. INGESTION:
HARMFUL IF SWALLOWED.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH LARGE AMOUNTS OF WATER. GET MEDICAL
ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING. FLUSH AREA WITH
LARGE AMOUNTS OF WATER. IF IRRITATION OCCURS, GET MEDICAL
ATTENTION. INHALATION: MOV E TO FRESH AIR. IF NOT BREATHING, GIVE
CPR. IF BREATHING DIFFICULT, GIVE OXYGEN. GET MEDICAL ATTENTION.
INGESTION: DO NOT INDUCE VOMITING. DRINK LARGE AMOUNTS OF MILK OR
WATER. GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER, FOAM, CARBON DIOXIDE, AND DRY CHEMICALS.
Fire Fighting Procedures:WHEN FIRE FIGHTING, WEAR FULL PROTECTIVE
EQUIPMENT, INCLUDING SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:STRONG OXIDIZER.CONTACT WITH
FLAMMABLE/COMBUSTIBLE VAPORS AND ORGANIC MATERIALS MAY INITIATE
FIRE OR EXPLOSION.CONTACT WITH METALS MAY LIBERATE OXYGEN AND HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE IGNITION SOURCES. CONTAIN SPILL.
WEARING PROTECTIVE EQUIPMENT AND USING EXPLOSION-PROOF EQUIPMENT,
REMOVE BULK OF LIQUID. ADD DRY MATERIAL TO ABSORB REMAINING
LIQUID.PICK UP AND CONTAINERIZE FO R PRODUCT RECOVERY OR
DISPOSAL.FLUSH AREA W/WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, WELL-VENTILATED AREA
AWAY FROM HEAT AND OXIDIZABLE ORGANIC MATERIALS.
Other Precautions:DO NOT ALLOW THIS PRODUCT TO STAND IN AN OPEN
CONTAINER, AS WATER EVAPORATION CAN OCCUR AND IT MAY CONCENTRATE
THE PEROXIDE CONTENT TO POINT IT BECOMES SENSITIVE TO SHOCKS AND
CAN EXPLODE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF THE OSHA-PEL IS EXCEEDED, A NIOSH-APPROVED
RESPIRATOR WITH SUPPLIED AIR OR A SCBA IS REQUIRED.
Ventilation:USE LOCAL EXHAUST VENTILATION. USE MECHANICAL (GENERAL)
VENTILATION AS A SUPPLEMENT TO THE LOCAL EXHAUST SYSTEM.
Other Protective Equipment:RUBBER OR PVC SLICKER SUIT, RUBBER BOOTS.
PROVIDE AN EYE WASH STATION AND SAFETY SHOWER.
Work Hygienic Practices:WASH AFTER HANDLING AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:D3
Boiling Pt:B.P. Text:226F,108C
Melt/Freeze Pt:M.P/F.P Text:-27F,-33C
Spec Gravity:1.133
pH:3-5
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, COLORLESS LIQUID. SLIGHTLY PUNGENT,
IRRITATING ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ORGANICS, OTHER FLAMMABLE AND COMBUSTIBLE MATERIAL, CATALYTIC METALS,
REDUCING AGENTS, AND OTHER OXIDIZERS.
Stability Condition to Avoid:AVOID HOT STORAGE.
Hazardous Decomposition Products:DECOMPOSITION PRODUCES HEAT, STEAM,
AND LARGE VOLUMES OF OXYGEN.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF WASTE IN ACCORDANCE WITH LOCAL, STATE
AND FEDERAL REGULATIONS. THOROUGHLY WASH EMPTIED CONTAINERS WITH
WATER BEFORE DISPOSAL, RETURN TO MANUFACTURER, OR ANY OTHER
INDUSTRIAL USE.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ATLASTACRETE E RESIN PART A, 0572304
Kit Part:Y
CAGE:04503
CAGE:04503
============= Composition/Information on Ingredients =============
Ingred Name:BISPHENOL A DIGLYCIDL ETHER RESIN; (BISPHENOL-A EPOXY
RESIN)
CAS:25068-38-6
RTECS #:SL6475000
Fraction by Wt: 65-85%
Ingred Name:PROPANE,1,2-EPOXY-3-(O-TOLYOXY)-; (O-CRESYL GLYCIDYL ETHER)
CAS:2210-79-9
RTECS #:TZ3700000
Fraction by Wt: 15-35%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES: CONTACT MAY CAUSE
IRRITATION. SKIN: CONTACT MAY CAUSE IRRITATION. LONG TERM/REPEATED
CONTACT MAY CAUSE SENSITIZATION. INHAL: INHALATION RESULTS IN
IRRITATION TO THE RESPIRATORY TRACT & MU COUS TISSUES. CHRONIC
EFFECTS OF OVEREXPOSURE: IRRITATION, SENSITIZATION, DERMATITIS.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:ALLERGY, ECZEMA AND SKIN
CONDITIONS.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH CLEAR WATER FOR AT LEAST 15 MINUTES. GET
MEDICAL ATTENTION IMMEDIATELY. SKIN: WASH CONTACT AREA WITH MILD
SOAP AND CLEAN WATER. IF IRRITATION/SWELLING DEVELOP, GET MEDICAL
ATTENTION.INHAL: REMOVE TO FRESH AIR. IF BREATHING STOPS, BEGIN
ARTIFICIAL RESPIRATION. GET MEDICAL HELP. INGEST: HAVE VICTIM DRINK
LARGE VOLUMES OF WATER TO DILUTE. DO NOT INDUCE VOMIT. GET MED
ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:262F,128C
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP.
WATER MAY BE INEFTIVE.IF A LG AMT IS INVOLVED, EVACUATE AREA &
FIGHT FIRE FROM A SAFE DIST. COOL (SUPP DATA)
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT MATERIAL SUCH AS CLAY, SAND &
DIATOMACEOUS EARTH TO CLEAN UP SPILLS, AND PLACE IN CONTAINERS FOR
DISPOSAL. FOR LARGE SPILLS, DIKE AREA OF SPILL AND PUMP LIQUID INTO
HOLDING TANK. FLUSH A REA W/WATER. KEEP OUT OF WATER SUPPLY.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE. KEEP
CONTRS CLSD WHEN NOT IN USE. STORE UPRIGHT, AWAY FROM
HEAT/SPARKS/FIRE. AVOID CONT W/EYES/SKIN(OR CLTHG).
Other Precautions:REMOVE CONTAMD CLOTHES & DO NOT REWEAR UNTIL
THOROUGHLY CLEANED. DISCARD CONTAMINATED SHOES. AVOID BRTHG
VAPS/MIST. USE W/ADEQUATE VENTILATION. DO NOT TAKE INTERNALLY, FOR
INDUSTRIAL USE ONLY. KEEP OU T OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED ORGANIC VAPOR MASK IF TLV IS
EXCEEDED/USED IN CONFINED AREA.
Ventilation:LOCAL: PROVIDE VENT ADEQ TO KEEP EXPOSURE BELOW TLV & TO
REMOVE ANY ODORS & FUMES. MECH: ACCEPTABLE.
Other Protective Equipment:SAFETY SHOWER, EYE BATH, & PROTECTIVE
CLOTHING. APPLY PROTECTIVE SKIN CREAM TO EXPOSED AREAS.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRE FIGHT PROC: SURROUNDING AREA W/WATER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>250F,>121C
Vapor Pres:LOW
Vapor Density:HVR/AIR
Spec Gravity:1.1-1.2
Solubility in Water:INSOLUBLE
Appearance and Odor:AMBER COLOR LIQUID WITH CHARACTERISTIC ODOR.
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MINERAL ACIDS, BASES, AMINES AND MERCAPTANS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:ALDEHYDES, CARBON MONOXIDE &/OR CARBON
DIOXIDE.
Conditions to Avoid Polymerization:STRONG ACIDS, AMINES AND BASES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH APPLICABLE LOCAL,
STATE AND FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:DIESEL FUEL NO. 2
CAGE:0KB31
CAGE:0KB31
============= Composition/Information on Ingredients =============
Ingred Name:PETROLEUM MID-DISTILLATE (DIESEL FUEL NO. 2)
CAS:68476-34-6
Fraction by Wt: 100%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES- SLIGHT TO MODERATE
IRRITATION. SKIN- MODERATELY TO EXTREMELY IRRITATING. INHALATION-
IRRITATING TO MUCOUS MEMBRANES AND RESPIRATORY TRACT. INGESTION-
STOMACH IRRITATION, GASTRITIS, LOSS O F CONCIOUSNESS, HEMORRHAGING
OF THE LUNG AND INTERNAL ORGANS. CHRONIC: SKIN- DERMATITIS & KIDNEY
DAMAGE.
Explanation of Carcinogenicity:NIOSH RECOMMENDS THAT WHOLE DIESEL
EXHAUST BE REGARDED AS A "POTENTIAL OCCUPATIONAL CARCINOGEN".
Effects of Overexposure:SKIN- REDNESS, DRYING, BURNING OR BLISTERING OF
SKIN. INHALATION- INTOXICATION, HEADACHE, DIZZINESS, NAUSEA,
VOMITING AND LOSS OF COORDINATION.INGESTION- CONVULSIONS,
CYANOSIS, AND MILD EXCITATION.
Medical Cond Aggravated by Exposure:MAY AGGRAVATE PRE-EXISTING
DERMATITIS.
======================= First Aid Measures =======================
First Aid:EYES- FLUSH THOROUGHLY WITH WATER FOR AT LEAST 15 MIN. GET
MEDICAL ATTETNION.SKIN- COOL THE EXPOSED AREA IMMEDIATELY. REMOVE
CONTAMINATED CLOTHING. IMMEDIATELY WASH AFFECTED AREAS WITH SOAP
AND WATE R. INHALATION- REMOVE TO FRESH AIR. APPLY ARTIFICIAL
RESPIRATION IF NOT BREATHING. GET MEDICAL ATTENTION. INGESTION- DO
NOT INDUCE VOMITING. KEEP VICTIM'S HEAD LOWER THAN HIPS IN CASE OF
VOMITING.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:125F,52C
Autoignition Temp:Autoignition Temp Text:495F
Lower Limits:0.6
Upper Limits:7.5
Extinguishing Media:DRY CHEMICAL, CARBON DIOXIDE, FOAM, AND WATER.
Fire Fighting Procedures:USE A WATER SPRAY TO COOL FIRE-EXPOSED
CONTAINERS. USE A SMOTHERING TECHNIQUE FOR EXTINGUISHING FIRE OF
THIS COMBUSTIBLE MATERIAL. WEAR FULL SCBA GEAR.
Unusual Fire/Explosion Hazard:FLOWING OIL CAN BE IGNITED BY
SELF-GENERATED STATIC ELECTRICITY.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE SOURCES OF HEAT OR IGNITION INCLUDING
INTERNAL COMBUSTION ENGINES AND POWER TOOLS. CLEAN-UP SPILL, BUT DO
NOT FLUSH TO SEWER OR SURFACE WATER. VENTILATE AREA AND AVOID
BREATHING VAPORS OR MISTS .
Neutralizing Agent:NONE
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN TIGHTLY CLOSED CONTAINERS IN
A DRY, COOL PLACE, AWAY FROM SOURCES OF HEAT OR IGNITION. GROUND
AND BOND ALL TRANSFER AND STORAGE EQUIPMENT.
Other Precautions:EMPTY CONTAINERS MAY CONTAIN RESIDUE AND CAN BE
DANGEROUS. DO NOT PRESSURIZE, CUT, WELD, BRAZE, SOLDER, DRILL,
GRIND OR EXPOSE SUCH CONTAINERS TO HEAT, FLAME, SPARKS OR OTHER
SOURCES OF IGNITION; THEY MAY EXPLODE AND CAUSE INJURY OR DEATH.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE APPROVED RESPIRATORY PROTECTIVE EQUIPMENT
FOR CLEANING LARGE SPILLS OR ENTRY INTO LARGE TANKS, VESSELS OR
OTHER CONFINED SPACES.
Ventilation:PROVIDE ADEQUATE VENTILATION TO MEET OCCUPATIONAL EXPOSURE
LIMITS AND PREVENT THE FORMATION OF EXPLOSIVE.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:THOROUGHLY WASH HANDS AFTER HANDLING THIS
MATERIAL.
Supplemental Safety and Health
DO NOT WEAR CONTACT LENSES WHERE CONTACT WITH LIQUID OF MIST MAY OCCUR.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:300F,149C
Vapor Pres:1.6 @ 20C
Vapor Density:8
Spec Gravity:0.87
Viscosity:1.9 CST @ 40C
Evaporation Rate & Reference:0.01 (NO REFERENCE GIVEN)
Solubility in Water:INSOLUBLE
Appearance and Odor:CLEAR TO LIGHT AMBER LIQUID. MILD PETROLEUM ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT, SPARK, FLAME AND BUILD-UP OF STATIC
ELECTRICITY.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
SULFUR DIOXIDE, AND HYDROCARBONS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE THROUGH A LICENSED WASTE DISPOSAL
COMPANY. FOLLOW FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:3M TYPE 164 TONER
CAGE:NO632
CAGE:NO632
============= Composition/Information on Ingredients =============
Ingred Name:STYRENE-BUTYL ACRYLATE POLYMER WITH INGRED #2
CAS:25767-47-9
Fraction by Wt: 60-95%
Other REC Limits:NONE RECOMMENDED
Ingred Name:STYRENE ACRYLIC RESIN WITH INGRED #1
CAS:58353-09-6
Fraction by Wt: SEE #1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:C.I. SOLVENT BLACK 7
CAS:8005-02-5
Fraction by Wt: 3-7%
Other REC Limits:NONE RECOMMENDED
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3; 9596
Ingred Name:POLYPROPYLENE
CAS:9003-07-0
RTECS #:TR5000000
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SILICA GEL
CAS:112945-52-5
RTECS #:VV7310000
Fraction by Wt: 0.1-1.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:6 MG/M3
ACGIH TLV:10 MG/M3
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: MECHANICAL EYE IRRITATION. SKIN:
MECHANICAL SKIN IRRITATION. INHALATION: IRRITATION (UPPER
RESPIRATORY). INGESTION: IRRITATION OF GASTROINTESTINAL TISSUES.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYE-REDNESS, SCRATCHING OF THE CORNEA AND
TEARING. SKIN-ITCHING AND REDNESS. INHALATION-SORENESS OF THE NOSE
AND THROAT , COUGHING AND SNEEZING. SWALLOWED-ABDOMINAL PAIN.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH WITH LARGE AMOUNTS OF WATER. GET
IMMEDIATE MEDICAL ATTENTION. SKIN: WASH AFFECTED AREA WITH SOAP AND
WATER. INHALATION: IF SIGNS/SYMPTOMS OCCUR, REMOVE PERSON TO FRESH
AIR. IF SIGNS/SYMPTOMS CONTINUE, CALL A PHYSICIAN. SWALLOWED: DO
NOT INDUCE VOMITING. DRINK 2 GLASSES OF WATER. CALL A PHYSICIAN.
===================== Fire Fighting Measures =====================
Autoignition Temp:Autoignition Temp Text:N/DETR
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING, INCLUDING
HELMET, SELF-CONTAINED, POSITIVE PESSURE OR PRESSURE DEMAND
BREATHING APPARATUS, BUNKER COAT AND PANTS.
Unusual Fire/Explosion Hazard:DUST CLOUDS OF THIS MATERIAL IN
COMBINATION WITH AN IGNITION SOURCE MAY BE EXPLOSIVE.
================== Accidental Release Measures ==================
Spill Release Procedures:OBSERVE PRECAUTIONS FROM OTHER SECTIONS. USE
WET SWEEPING COMPOUND OR WATER TO AVOID DUSTING. CLEAN UP RESIDUE.
OLACE IN A CLOSED CONTAINER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED WHEN NOT IN USE.
KEEP OUT OF REACH OF CHILDREN. STORE AT TEMPERATURES BELOW 95
DEGREES F. KEEP CONTAINER TIGHTLY CLOSED.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AVOID BREATHING OF DUST.
Ventilation:PROVIDE SUFFICIENT VENTILATION TO MAINTAIN EMISSIONS BELOW
RECOMMENDED EXPOSURE LIMITS.
WHICH EXPOSURE IS LIKELY.
Work Hygienic Practices:WASH HANDS AFTER HANDLING AND BEFORE EATING.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:V7
Spec Gravity:0.30-0.50
Viscosity:NP
Solubility in Water:NIL
Appearance and Odor:FINE BLACK POWDER, ESSENTIALLY ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
HYDROCARBONS, ALDEHYDES,KETONS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF WASTE PRODUCT IN A SANITARY LANDFILL.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:4-CHLOROBENZENAMINE, O-363
CAGE:84898
CAGE:84898
CAGE:8Y898
============= Composition/Information on Ingredients =============
Ingred Name:ANILINE, P-CHLORO-; (P-CHLOROANILINE) (CERCLA)
CAS:106-47-8
RTECS #:BX0700000
OSHA PEL:N/K
ACGIH TLV:N/K
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50: (RAT) 310 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:SUSPECTED CARCINOGEN-MAY PRODUCE
CANCER. CAN BE FATAL IF INHALED! MAY BE FATAL IF SWALLOWED! CAN BE
FATAL IF ABSORBED THROUGH THE SKIN! CAN CAUSE EYE IRRITATION. CAN
CAUSE SKIN IRRITATION. CAN CAUSE C YANOSIS. CAN CAUSE DELAYED
ADVERSE HEALTH EFFECTS. CAN CAUSE LIVER INJURY. CAN CAUSE KIDNEY
INJURY.
Explanation of Carcinogenicity:P-CHLOROANILINE:IARC MONOGRAPHS ON THE
EVALUATION OF CARCIN RISK OF CHEMICALS TO MAN, VOL 57, PG 305,1993;
GROUP 2B.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:AN ANTIDOTE IS A SUBSTANCE INTENDED TO COUNTERACT EFTS OF
POISON. IT SHOULD BE ADMIN ONLY BY MD/TRAINED EMER PERS. MED ADVICE
CAN BE OBTAINED FROM POIS CTL CTR. IN CASE OF CONT:EYES:FLUSH
CONTINUOUSLY W/H*2O FOR AT LEAST 15-20 MIN. SKIN:FLUSH W/H*2O FOR
15-20 MIN. IF NO BURNS HAVE OCCURRED-USE SOAP & H*2O TO CLEANSE
SKIN. INHAL:REMOVE PATIENT TO FRESH AIR. ADMIN OXYGEN IF PATIENT IS
HAVING(SUPDAT)
===================== Fire Fighting Measures =====================
Flash Point:NOT AVAILABLE
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL POWDER OR WATER SPRAY.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE AREA. WEAR APPROPRIATE OSHA
NIOSH/MSHA-REGULATED EQUIPMENT. VENTILATE AREA. SWEEP UP AND PLACE
IN AN APPROPRIATE CONTAINER. HOLD FOR DISPOSAL. WASH CONTAMINATED
SURFACES TO REMOVE ANY RESIDUE S.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTACT WITH SKIN, EYES AND
CLOTHING. KEEP TIGHTLY CLOSED AND STORE IN A COOL DRY PLACE. STORE
ONLY WITH COMPATIBLE CHEMICALS.
Other Precautions:CONTACT LENSES SHOULD NOT BE WORN IN THE LABORTORY.
ALL CHEMICALS SHOULD BE CONSIDERED HAZARDOUS - AVOID DIRECT
PHYSICAL CONTACT!
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR FOR EXPOSURE
OF CONCERN ( ).
Ventilation:THIS CHEMICAL SHOULD BE HANDLED ONLY IN A HOOD.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRST AID PROC: DIFFICULTY BREATHING. IF PATIENT HAS STOPPED BREATHING
ADMINISTER ARTIFICIAL RESPIRATION. IF PATIENT IS IN CARDIAC ARREST
ADMINISTER CPR. CONTINUE LIFE SUPPORTING MEASURES UNTIL MEDICA L
ASSISTANCE HAS ARRIVED. REMOVE & WASHCONTAMINATED CLOTHING. GET
MEDICAL ATTENTION IF NECESSARY.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:450F,232C
Melt/Freeze Pt:M.P/F.P Text:>154F,>68C
Solubility in Water:SOLUBLE IN HOT WATER
Appearance and Odor:WHITE CRYSTALLINE SOLID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
INCOMPATIBLE WITH STRONG ACIDS, CHLOROFORMATES, STRONG OXIDIZING
AGENTS. REACTS WITH ACID HALIDES AND ANHYDRIDES.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:LIBERATES TOXIC FUMES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH FEDERAL,
STATE AND LOCAL REGULATIONS . BURN IN A CHEMICAL INCINERATOR
EQUIPPED WITH AN AFTERBURNER AND SCRUBBER.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:FA6214A
CAGE:JO764
CAGE:81831
CAGE:JO764
============= Composition/Information on Ingredients =============
Ingred Name:POLYCHLORINATED BIPHENYLS (PCBS) (SARA III)
CAS:1336-36-3
RTECS #:TQ1350000
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Effects of Overexposure:ABSORBED THRU SKIN,LUNGS,INTESTINE.CAUSES
CANCER,LIVER,KIDNEY,STOMACH,EYE,HEARING DISORDER(SUP DATA)
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/WATER IMMEDIATELY.SKIN:WASH W/SOAP
IMMEDIATELY.INHAL:REMOVE TO FRESH AIR,GIVE ART.RESPIR.AS
NEEDED.INGEST:GET MEDICAL ATTN.GIVE LARGE QTY OF SALT WATER,INDUCE
VOMITING,BUT DO NOT MAKE UNC ONSCIOUS PERSON VOMIT.
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT & DIKES TO PREVENT
RUNOFF.ISOLATE & NOTIFY PROPER AUTHORITIES.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE MUST FOLLOW RCRA REQUIREMENTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SUPPLIED AIR W/FULL FACEPIECE,HELMET OR HOOD
Ventilation:LOCAL EXHAUST
Other Protective Equipment:FULL CLOTHING TO PREVENT SKIN CONTACT
Supplemental Safety and Health
OVEREXPOS:CAN CAUSE FORMATION OF CYSTS,CAUSES STILLBIRTHS.IRRITATES
EYES,NOSE THROAT.
================== Physical/Chemical Properties ==================
HCC:Z3
Appearance and Odor:LIGHT STRAW-COLORED LIQUID,AROMATIC ODOR
================= Stability and Reactivity Data =================
STRONG OXIDIZERS
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-GENERALLY HIGH
TEMPERATURE INCINERATION.ONLY APPROVED DISPOSAL OPERATOR PERMITTED.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:EPIBOND 1543A
CAGE:OO131
CAGE:0EJE3
CAGE:OO131
============= Composition/Information on Ingredients =============
Ingred Name:EPOXY RESINS
Fraction by Wt: >70%
Other REC Limits:NONE SPECIFIED
Ingred Name:INORGANIC INERT FILLERS
Fraction by Wt: <20%
Other REC Limits:NONE SPECIFIED
Ingred Name:SILICON DIOXIDE
CAS:60676-86-0
RTECS #:VV7320000
Fraction by Wt: <10%
Other REC Limits:NONE SPECIFIED
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
Ingred Name:ALUMINUM PIGMENTS
Fraction by Wt: <10%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50: >1,000 MG/KG(RAT); DERMAL *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Health Hazards Acute and Chronic:INHALATION: VAPOR CAN BE HARMFUL IF
INHALED. EYE CONTACT: MODERATELY IRRITATING TO EYES. SKIN: SLIGHTLY
IRRITATING TO SKIN. INGESTION: POSSIBLY BE HARMFUL IF SWALLOWED.
PROLONGED OR REPEATED EXPOSURE CAN CAUSE ALLERGIC REACTION.
Explanation of Carcinogenicity:N/K *LD50: >3,000 MG/KG (RABBIT)
======================= First Aid Measures =======================
First Aid:INHALATION: MOVE SUBJECT TO FRESH AIR. EYE AND SKIN CONTACT:
FLUSH EYES WITH A LARGE AMOUNT OF WATER FOR AT LEAST 15 MINUTES.
GET PROMPT MEDICAL ATTENTION. WASH SKIN THOROUGHLY WITH SOAP AND
WATER. RE MOVE AND WASH CLOTHING BEFORE REUSE. INGESTION: IF
SWALLOWED, DILUTE BY GIVING 2 GLASSES OF WATER TO DRINK. SEE A
PHYSICIAN. NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>200F,>93C
Extinguishing Media:CO2, DRY CHEMICAL, WATER SPRAY.
Fire Fighting Procedures:WEAR BREATHING APPARATUS (PRESSURE DEMAND,
MSHA/NIOSH-APPROVED OR EQUIVALENT) AND FULL PROTECTIVE GEAR.
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN UP ALL TRACES OF SPILL. SHOVEL AS MUCH
OF MATERIAL AS POSSIBLE INTO CLEAN, DRY CONTAINERS. ON HARD
SURFACES, USE ABSORBENT MATERIAL TO PICK UP REMAINDER; ON LOOSE
SURFACES, SHOVEL UP CONTAMINATE D LAYER.
======================Handling and Storage ======================
Handling and Storage Precautions:MAXIMUM 35 C. AVOID ALL SKIN CONTACT.
MAY CAUSE ALLERGIC REACTION. WASH EXPOSED AREA THOROUGHLY WITH SOAP
AND WATER AFTER HANDLING THIS MATERIAL.
Other Precautions:STORE INDOORS IN A COOL, DRY AREA WITH ADEQUATE
VENTILATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED IF GOOD VENTILATION IS MAINTAINED.
WEAR RESPIRATOR (MSHA/NIOSH-APPROVED) SUITABLE FOR CONCENTRATIONS
AND TYPE OF AIR CONTAMINANTS ENCOUNTERED.
Ventilation:NORMAL ROOM VENTILATION.
Other Protective Equipment:SAFETY SHOWER AND EYEWASH FACILITY.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Vapor Density:>1
Spec Gravity:1.24
Viscosity:THICK PASTE
Evaporation Rate & Reference:<1 (BUAC=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:ALUMINUM COLOR THICK PASTE; CHARACTERISTIC ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, ACIDS, ALKALIES AND AMINES.
Stability Condition to Avoid:AVOID STORAGE TEMPERATURES ABOVE 100 F.
Hazardous Decomposition Products:CARBON MONOXIDE AND CARBON DIOXIDE.
Conditions to Avoid Polymerization:HEAT, ACIDS, ALKALIES AND AMINES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DILUTE WITH A SUITABLE FLAMMABLE SOLVENT; THEN
INCINERATE IN APPROVED EQUIPMENT. INCINERATE OR LANDFILL
CONTAMINATED DIKING MATERIAL IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ATLASTACRETE F RESIN PART A, 0572314
Kit Part:Y
CAGE:04503
CAGE:04503
============= Composition/Information on Ingredients =============
Ingred Name:FURFURYL ALCOHOL
CAS:98-00-0
RTECS #:LU9100000
Fraction by Wt: 90-100%
OSHA PEL:S, 50 PPM/15 STEL
ACGIH TLV:S,10 PPM/15STEL;9293
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE:CONTACT CAUSES IRRITATION. MAY
CAUSE REDNESS, TEARING AND BLURRED VISION. SKIN:MAY CAUSE
IRRITATION. INHAL:MAY RESULT IN IRRITATION TO RESPIRATORY TRACT AND
MUCOUS TISSUES, MAY ALSO CAUSE NAUSEA, DROWSINESS AND HEADACHE.
CHRONIC:RESPIRATORY PROBLEMS.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:RESPIRATORY PROBLEMS, ALLERGIES.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH WITH WATER WHILE LIFTING EYELIDS & ROLLING EYES,
FOR AT LEAST 15 MINUTES. GET MD. SKIN:REMOVE CONTAMINATED CLOTHING
& SHOES. WASH CONTACT AREA WITH SOAP & CLEAN WATER. WASH CLOTHING
BEFORE R EUSING. DISCARD CONTAMINATED SHOES. INHAL:MOVE TO FRESH
AIR. IF BREATHING STOPS GIVE ARTIFICIAL RESPIRATION, GET MD.
INGEST:IF CONSCIOUS, GIVE 2 GLASSES OF WATER AND INDUCE VOMITING.
GET MD.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:180F,82C
Lower Limits:0.8%
Upper Limits:6.3%
Extinguishing Media:WATER SPRAY, CO*2, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:MAY POLYMERIZE VIOLENTLY IN PRESENCE OF
STRONG ACIDS.
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT MATERIALS SUCH AS CLAY, SAND OR
DIATOMACEOUS EARTH TO CLEAN UP SPILLS. PLACE IN COVERED CONTAINERS
FOR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL DRY PLACE. KEEP
CONTAINERS CLOSED WHEN NOT IN USE. DO NOT TAKE INTERNALLY.
Other Precautions:FOR INDUSTRIAL USE ONLY. KEEP OUT OF REACH OF
CHILDREN. AVOID DIRECT CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED ORGANIC VAPOR MASK IF TLV IS
EXCEEDED OR USE IN CONFINED AREAS.
Ventilation:LOCAL:PROVIDE VENTILATION ADEQUATE TO KEEP EXPOSURE BELOW
TLV. MECHANICAL:ACCEPTABLE.
Other Protective Equipment:EYE BATH AND PROTECTIVE CLOTHING. COVER ARMS
& LEGS.
Work Hygienic Practices:WASH HANDS & FACE THOROUGHLY AFTER HANDLING &
BEFORE EATING, DRINKING OR SMOKING. DO NOT WEAR CONTACT LENSES.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:340F,171C
Vapor Pres:1 @ 89F
Vapor Density:3.4
Spec Gravity:1.131
Evaporation Rate & Reference:LESS THAN BUTYL ACETATE
Solubility in Water:NONE
Appearance and Odor:BROWN LIQUID WITH MILDLY IRRITATING ODOR
Percent Volatiles by Volume:90
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MINERAL ACIDS, ORGANIC ACIDS.
Stability Condition to Avoid:DO NOT STORE NEAR STRONG ACIDS, OXIDIZERS
OR PEROXIDES. AVOID EXPOSURE TO EXCESSIVE HEAT.
Hazardous Decomposition Products:CARBON MONOXIDE AND/CARBON DIOXIDE.
Conditions to Avoid Polymerization:ADDITION OF STRONG ACIDS DIRECTLY TO
THE RESIN.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH APPLICABLE LOCAL,
STATE AND FEDERAL ENVIRONMENTAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:3010/4030/4030II/4197 MICR TONER/DEVELOPER(
CAGE:0E6G9
CAGE:0E6G9
CAGE:26921
============= Composition/Information on Ingredients =============
Ingred Name:IRON OXIDE
CAS:1317-61-9
Fraction by Wt: 45-55%
OSHA PEL:10 MG/M3 TDUST
ACGIH TLV:5 MG/M3 FUME
Ingred Name:STYRENE-ACRYLIC COPOLYMER
CAS:25767-47-9
Fraction by Wt: 40-45%
Ingred Name:PROPENE POLYMERS; (POLYOLEFIN)
CAS:9003-07-4
RTECS #:UD1842000
Fraction by Wt: <5%
Ingred Name:SILICA GEL; (AMORPHOUS SILICA)
CAS:112945-52-5
RTECS #:VV7310000
Fraction by Wt: <2%
Ingred Name:DYE; (CHROMIUM/AZO DYE COMPLEX). OTHER CAS #'S:
109125-50-0, 109125-51-1.
CAS:84179-66-8
Fraction by Wt: <1%
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50: (ORAL,RAT) >5 G/KG.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: MINIMAL RESPIRATORY TRACT
IRRITATION MAY OCCUR AS WITH EXPOSURE TO LARGE AMOUNTS OF ANY
NON-TOXIC DUST.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NONE WHEN USED AS DESCRIBED BY
PRODUCT LITERATURE.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR AT LEAST 15 MINUTES. SKIN: WASH
WITH SOAP AND WATER. INHALATION: REMOVE FROM EXPOSURE. INGESTION:
DILUTE STOMACH CONTENTS WITH SEVERAL GLASSES OF WATER.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER, DRY CHEMICAL, CARBON DIOXIDE OR FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . AVOID INHALATION OF SMOKE.
Unusual Fire/Explosion Hazard:TONER IS COMBUSTIBLE POWDER. LIKE MOST
ORGANIC MATERIALS IN POWDER FORM, WHEN DISPERSED IN AIR, IT CAN
FORM EXPLOSIVE MIXTURES.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP/VACUUM SPILLED TONER & CAREFULLY
TRANSFER INTO SEALABLE WASTE CNTNR.SWEEP SLOWLY TO AVOID MAKING
LOOSE TONER AIRBORNE.IF VACUUM IS USED, MOTOR MUST BE RATED AS DUST
TIGHT. A CONDUCTIVE HOSE B ONDED TO MACHINE SHD BE USED TO REDUCE
(SUPP DATA)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE WITH ADEQUATE VENTILATION.
Other Precautions:AVOID PROLONGED INHALATION OF EXCESSIVE DUST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED WHEN USED AS INTENDED IN XEROX
EQUIPMENT. WEAR NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:FOR USE OTHER THAN NORMAL CUSTOMER-OPER PROC
(SUCH AS IN BULK TONER PROCESSING FACILITIES), GOG& RESP MAY BE
(SUPP DATA)
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
TRADE NAME/PART #: CARTRIDGE/DRY INK CARTRIDGE, XCI 6R539. SPILL PROC:
STATIC BUILDUP. RESIDUE CAN BE REMOVED W/SOAP AND COLD WATER.
GARMENTS MAY BE WASHED OR DRY CLEANED, AFTER REMOVAL OF LOOSE TONER
. OTHER PROT EQUIP: REQUIRED. FOR MORE INFORMATION, CONTACT XEROX.
================== Physical/Chemical Properties ==================
HCC:V7
Spec Gravity:1.7
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLACK POWDER/FAINT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:PRODUCTS OF COMBUSTION MAY BE TOXIC.
AVOID BREATHING SMOKE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE,
AND LOCAL REGULATIONS. INCINERATE ONLY IN CLOSED CONTAINER.
| 0 | eyes_protection_not_mandatory |
===================== Product Identification =====================
Product ID:ETHYLENE DICHLORIDE
CAGE:GO796
CAGE:47695
CAGE:GO796
============= Composition/Information on Ingredients =============
Ingred Name:ETHYLENE DICHLORIDE (SARA III)
CAS:107-06-2
RTECS #:KI0525000
Fraction by Wt: 100%
OSHA PEL:50 PPM/C,100PPM
ACGIH TLV:10 PPM; 9293
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
Effects of Overexposure:INHAL/INGES/SKIN
ABSORPTION:HEADACHE,DIZZINESS,INTERNA BLEEDING AND DEATH,LIVER OR
KIDNEY DAMAGE.S.D
======================= First Aid Measures =======================
First Aid:INHALE:REMOVE TO FRESH AIR, GIVE CPR/O*2 IF
NEED;EYES/SKIN:FLUSH W LG AMTS H*2O FOR 15 MIN;INGEST:RINSE MOUTH;
GET MEDICAL ATTENTION FOR EYES, BREATHING DIFFICULTY, OR OTHER
SYMPTOMS OF OVEREXPOSURE.
===================== Fire Fighting Measures =====================
Flash Point:65F/18.3C (O.C.)
Lower Limits:8.25
Upper Limits:15.9
Extinguishing Media:DRY CHEMICALS,FOAM,CO*2.
Fire Fighting Procedures:COOL CNTRS WITH WATERSPRAY.USE SCBA IN FIRES &
CONFINED AREA
Unusual Fire/Explosion Hazard:TOXIC CORROSIVE FUMES OF HCL AND PHOSGENE
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION.REMOVE ALL
SOURCES OF IGNITION.COLLECT SPILLED MATERIAL ON SAW DUST,OR
VERMICULITE.SWEEP UP AND HOLD IN CLOSED CONTAINERS FOR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL AREA.PROVIDE ADEQUATE
VENTILATION.KEEP AWAY FROM FLAMES AND TIGHTLY CLOSED WHEN NOT IN
USE.
Other Precautions:AVOID SKIN AND EYE CONTACT.DO NOT BREATHE VAPORS.DO
NOT TAKE INTERNALLY.SWALLOWING MAY CAUSE INJURY OR DEATH.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED RESPIRATOR FOR ORGANIC VAPORS
OR SCBA
Ventilation:LOCAL EXHAUST TO MAINTN BELOW TLV.
Other Protective Equipment:FULL PROTECTIVE CLOTHING,SAFETY SHOWER,EYE
WASH STATION
Supplemental Safety and Health
MSDS DATED OCT 1978;INGREDIENT:ETHYLENE DICHLORIDE IS A SUSPECTED
CARCINOGEN/PER NTP.USE EXTRA PRECAUTION WHEN USING THIS ITEM.
================== Physical/Chemical Properties ==================
HCC:F5
Boiling Pt:B.P. Text:181F/83C
Vapor Pres:87
Vapor Density:3.4
Spec Gravity:1.255
Evaporation Rate & Reference:<1.0 (ETHYL ETHE=1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:COLORLESS LIQUID;SWEAT CHLOROFORM TYPE ODOR.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIALS
Stability Condition to Avoid:FLAMES,HEAT,ELECTRIC ARCS.
Hazardous Decomposition Products:HCL GAS AND TRACES OF PHOSGENE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF COLLECTED MATERIAL IN ACCORDANCE WITH
LOCAL, STATE & FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ACETONE
CAGE:5A188
CAGE:5A188
CAGE:0HF19
CAGE:3P400
============= Composition/Information on Ingredients =============
Ingred Name:ACETONE (SARA III)
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 100%
OSHA PEL:1000PPM
ACGIH TLV:750PPM/1000STEL;9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT) IS 9750 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES:CAUSES
IRRITATION,REDNESS,TEARING; SKIN:CAN CAUSE SLIGHT IRRITATION;
INHALE:EXCESSIVE INHALATION OF VAPORS CAN CAUSE NASAL AND
RESPIRATORY IRRITATION,CENTRAL NERVOUS SYSTEM EFFECTS INCLUDING
DIZZ INESS,WEAKNESS,FATIGUE,NAUSEA,ETC.; INGEST:CAUSES
GASTROINTESTINAL IRRITATION,NAUSEA,VOMITING & DIARRHEA.
Explanation of Carcinogenicity:THERE ARE NO INGREDIENTS ABOVE 0.1%
WHICH ARE IDENTIFIED AS CARCINOGENS BY NTP,IARC OR OSHA.
Effects of Overexposure:SKIN:REMOVE CONTAMINATED CLOTHING.WASH WITH
SOAP AND WATER.GET MEDICAL HELP IF IRRITATION PERSISTS;
INHALATION:REMOVE TO FRESH AIR & RESTORE BREATHING IF NECESSARY.GET
MEDICAL HELP; EYE: IMMEDIATELY F LUSH WITH WATER FOR 15 MINUTES
WHILE HOLDING EYELIDS OPEN.CALL APHYSICIAN; INGESTION:IMMEDIATELY
CALL A PHYSICIAN.NO VOM
Medical Cond Aggravated by Exposure:NONE STATED
======================= First Aid Measures =======================
First Aid:SKIN:WASH EXPOSED AREA WITH SOAP & WATER, REMOVE CONTAMINATED
CLOTHING,LAUNDER BEFORE REUSE; EYE:FLUSH WITH LARGE AMOUNTS OF
WATER,LIFTING UPPER AND LOWER LIDS OCCATIONALLY,GET MEDICAL
ATTENTION; INGE ST:DRINK TWO GLASSES OF WATER & INDUCE VOMITING BY
GIVING IPECAC SYRUP OR PLACING FINGER AT BACK OF THROAT,GIVE
NOTHING TO UNCONSCIOUS PERSON; INHALE:REMOVE TO FRESH AIR,USE
OXYGEN IF NEEDED.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:0F/-17.8C
Lower Limits:2.6
Upper Limits:12.8
Extinguishing Media:ALCOHOL FOAM OR CARBON DIOXIDE OR DRY CHEMICAL.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS WIT A
FULL FACEPIECE OPERATED IN THE POSITIVE PRESSURE DEMAND MODE WHEN
FIGHTING FIRES.
Unusual Fire/Explosion Hazard:NEVER USE WELDING OR CUTTING TORCH ON OR
NEAR DRUM BECAUSE PRODUCT CAN IGNITE EXPLOSIVELY.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB LIWUED ON PAPER, VERMICULITE, FLOOR
ABSORBENT, OR OTHER ABSORBENT MATERIAL AND TRANSFER TO HOOD.
Neutralizing Agent:NOT APPLICABLE.
======================Handling and Storage ======================
Handling and Storage Precautions:CONTAINERS OF THIS MATERIAL MAY BE
HAZARDOUS WHEN EMPTIED SINCE EMPTIED CONTAINERS RETAIN PRODUCT
RESIDUES.
Other Precautions:PREVENT REPEATED OR PROLONGED SKIN CONTACT, WEAR
IMPERVIOUS CLOTHING AND BOOTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF TLV IS EXCEEDED, USE A NIOSH/MSHA APPROVED
AIR SUPPLIED RESPIRATOR IS ADVISED; OSHA REGULATION ALSO PERMIT
OTHER NIOSH/ MSHA RESPIRATORS UNDER SPECIFIED CONDITIONS.
Ventilation:PROVIDE SUFFICIENT MECHANICAL VENTILATION TO MAINTAIN
EXPOSURE BELOW TLV.
Other Protective Equipment:IMPERVIOUS CLOTHING AND BOOTS.
Work Hygienic Practices:USE GOOD PERSONAL HYGIENE PRACTICES.WASH HANDS
AFTER EACH USE OF PRODUCT.DO NOT EAT/DRINK/SMOKE IN WORK AREA.SHOWR
AFTER
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:133F/56.1C
Vapor Pres:181
Spec Gravity:0.788
pH:7
Evaporation Rate & Reference:14.4 (BUTYL ACETATE =1)
Appearance and Odor:LIQUID, SOLVENT ODOR.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS,STRONG ALKALIE STRONG
MINERAL ACIDS.
Stability Condition to Avoid:NONE STATED
Hazardous Decomposition Products:CARBON DIOXIDE AND/OR CARBON MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE
AND FEDERAL REGUALTIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Preparer's Name:DOD HMIS/DGSC-SSH
CAGE:JO772
CAGE:14153
CAGE:JO772
============= Composition/Information on Ingredients =============
Ingred Name:ASBESTOS, CHRYSOTILE
CAS:12001-29-5
RTECS #:CI6478500
OSHA PEL:0.2 FIBERS/CC
ACGIH TLV:2 FIBERS/CC; A1;9192
Ingred Name:GENERIC "MSDS". SPECIFIC ASBESTOS TYPE NOT KNOWN. ONE
CITED IS ASSUMED. INFORMATION BASED ON SEGMENT "M" OF "DLSC TIR"
RTECS #:9999999ZZ
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: NO ACUTE EFFECTS ARE KNOWN;
CHRONIC: DUST FROM ABRASIVE ACTIONS(EG. CUTTING, MACHINING,
FILING, ETC.) MAYCONTAIN ASBESTOS FIBERS. CHRONIC OVEREXPOSURE
TO AIRBORNE FIBERS MAY LEAD TO ASBESTOSIS & MESOTHELIOMA.
SMOKINGCOMBINED W/FIBER INHALATION GREATLY INCREASES LUNG
CANCER RISK!
Explanation of Carcinogenicity:OVEREXPOSURE TO AIRBORNE CONCENTRATIONS
OF ASBESTOS MAY LEAD TO ASBESTOSIS AND MESOTHELIOMA.
Effects of Overexposure:INHAL: INHALATION OF AIRBORNE DUST CONTAINING
ASBESTOS FIBERS ON REPEATED EXPOSURE MAY CAUSE OR CAN LEAD TO
ASBESTOSIS/ MESOTHELIOMA; SKIN: N/K; EYE: POTENTIAL IRRITATION
FROM AIRBORNE DUST; INGEST: N/K.
Medical Cond Aggravated by Exposure:RESPIRATORY DEFICIENCIES DUE TO
REPEATED INHALATION OF AIRBORNE FIBERS.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. OBTAIN MEDICAL ADVICE; SKIN:
WASH EXPOSED AREA WITH SOAP & WATER; EYE: FLOOD W/ WATER. IF
IRRITATION OCCURS, GET MEDICAL ATTN; INGEST: CONSULT A
PHYSICIAN; OTHER: CHANGE CLOTHING AS REQUIRED TO AVOIDCARRYING
DUST PARTICLES INTO OTHER AREAS
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:MATERIAL IS NOT FLAMMABLE ; USE MEDIA APPROPRIATE
FOR SURROUNDING FIRE.
Fire Fighting Procedures:COMBUSTION PRODUCTS OF THIS MATERIAL MAY BE
TOXIC. USE A SELF-CONTAINED BREATHING APPARATUS WHEN FIGHTING FIRES
INVOLVING CHEMICAL PRODUCTS.
Unusual Fire/Explosion Hazard:NONE KNOWN
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION. VACUUM OR WET
CLEAN IF DUST IS INVOLVED. ANY VACUUM SYSTEM SHOULD BE EQUIPPED W/
AN OUTLET "HEPA" FILTER TO PREVENT REINTRODUCING ASBESTOS FIBERS TO
THE ATMOSPHERE.
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLE IN A MATTER TO MINIMIZE
FORMATION OR RETENTION OF AIRBORNE DUST. USE PROPER PERSONAL
PROTECTION FOR TASK AT HAND. CHECK W/YOUR SAFETY OFFICE!!!
Other Precautions:AS MANUFACTURED, LOCKED-IN ASBESTOS DOES NOT PRESENT
A HAZARD. ONLY WHEN THE ITEM IS SUBJECTED TO ABRASIVE ACTIONS &
DUST IS GENERATED, THEN ASBESTOS FIBERS MAY BE RELEASED & BECOME
AIRBORNE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF EXPOSURES EXCEED ESTABLISHED LIMITS, A
NIOSH/MSHA APPROVED RESPIRATOR FOR ASBESTOS SHOULD BE USED.
CONSULT YOUR SAFETY OFFICE/IH PERSONNEL FOR GUIDANCE FOR THE TASK
AT HAND.
Ventilation:LOCAL EXHAUST IS RECOMMENDED IN SITUATIONS WHERE DUST IS
GENERATED BY ABRASIVE ACTIONS, ABRASION OR OTHER MEANS.
Other Protective Equipment:AS REQUIRED FOR TASK AT HAND, AND THE
GUIDANCE SET FORTH BY YOUR SAFETY OFFICE OR IH PERSONNEL
Work Hygienic Practices:DONOT INHALE DUST CREATED BY ABRADING ACTIONS.
USE FULL PROTECTION AGAINST AIRBORNE FIBERS. AVOID AIRBORNE DUST
CREATION
Supplemental Safety and Health
GENERIC "MSDS" CREATED FOR "NSN" IDENTIFIED BY "DISC" AS CONTAINING
ASBESTOS.WHEN A MANUFACTURER'S SPECIFIC "MSDS" IS PROVIDED FOR
MATERIAL PROCURED UNDER THIS NSN, THIS GENERIC "MSDS" WILL BE
REMOVED.
================== Physical/Chemical Properties ==================
HCC:T6
Evaporation Rate & Reference:NONE
Solubility in Water:NOT SOLUBLE
Appearance and Odor:MANUFACTURED COMMODITY DESCRIBED BY LOGISTICS:
"ITEM-NAME"
Percent Volatiles by Volume:NONE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:NONE KNOWN
==================== Disposal Considerations ====================
Waste Disposal Methods:DUST SHOULD BE HANDLED AS A HAZARDOUS AIR
POLLUTANT I/A/W 40CFR61 SUBPART "M" PERTAINING TO ASBESTOS. USE
LANDFILLS APPROVED FOR ASBESTOS DISPOSAL. NOTE IF ITEM UNDER
CONSIDERATION FOR DISPOSAL IS "FRIABLE OR NON-FRIABLE".
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:MIL-C-450C TYPE II
Preparer's Name:J.J. BURGARD
CAGE:82925
CAGE:82925
============= Composition/Information on Ingredients =============
Ingred Name:PETROLEUM NAPHTHA
Fraction by Wt: 20-25%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:500 PPM
ACGIH TLV:400 PPM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE-MAY CAUSE IRRITATION & CHEMICAL
CONJUNCTIVITIS. INHALATION-MAY CAUSE UPPER RESPIRATORY TRACT
IRRITATION. CNS DEPRESSION MAY ALSO OCCUR. INGESTION-WILL CAUSE
PAIN AND IRRITATION TO GASTROINTESTINAL TRACT.
Explanation of Carcinogenicity:THIS PRODUCT CONTAINS CARCINOGENS (NTP,
IARC OR OSHA): NO.
Effects of Overexposure:SKIN-MAY CAUSE DRYING AND CRACKING OF THE SKIN.
INHALATION-A BURNING SENSATION IN THE CHEST MAY BE PRESENT.
INGESTION-NAUSEA, VOMITING AND DIARRHEA.
Medical Cond Aggravated by Exposure:NO DATA AVAILABLE.
======================= First Aid Measures =======================
First Aid:EYE-FLOOD WITH WATER FOR AT LEAST 15 MINUTES. GET MEDICAL
ATTENTION. SKIN-WASH EXPOSED AREA WITH MILD SOAP AND WATER. IF
IRRITATION PERSISTS. GET MEDICAL ATTENTION. INHALATION-MOVE VICTIM
TO FRESH AIR . WHEN REQUIRED ASSIST WITH VENTILATION, GET MEDICAL
ATTENTION. INGESTION-DO NOT INDUCE VOMITING. ADMINISTER 4-8 OZ OF
WATER FOR DILUTION IF PRODUCT IS INGESTED. GET IMMEDIATE MEDICAL
ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:55.0F,12.8C
Autoignition Temp:Autoignition Temp Text:ND
Lower Limits:ND
Upper Limits:ND
Extinguishing Media:WATER SPRAY OR FOG, FOAM.
Fire Fighting Procedures:COOL FIRE EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:DIKE AREA OF SPILLL. ABSORB LIQUID WITH INERT
MATERIAL AND PLACE IN PROPER CONTAINER FOR DISPOSAL. DO NOT ALLOW
MATERIAL TO ENTER SEWERS, WATERWAYS OR WATER SUPPLIES. ALL CLEANUP
ACTIVITIES MUST COMPL Y WITH HAZWOPER (20CFR1910.120)
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL DRY PLACE. STORE AWAY
FROM STRONG ACIDS, OXIDIZERS AND POISONS. KEEP CONTAINER CLOSED
WHEN NOT IN USE.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF EXPOSURE MAY OR DOES EXCEED PERMISSIBLE
EXPOSURE LIMITS, THEN USE A NIOSH-APPROVED RESPIRATOR.
Ventilation:LOCAL EXHAUST: YES. MECHANICAL: EXPLOSION PROOF FAN.
Other Protective Equipment:PROVIDE LOCAL EMERGENCY SHOWERS AND EYE WASH
STATIONS. ALL USERS SHOULD CONSULT MSDS BEFORE HANDLING PRODUCT.
Work Hygienic Practices:ALWAYS WASH HANDS AND FACE AFTER USE. LAUNDER
CONTAMINATED CLOTHING BEFORE RE-USE.
Supplemental Safety and Health
OTHER ENGINEERING CONTROLS-USE AN EXPLOSION PROOF FAN. GROUND ALL
EQUIPMENT.
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:>120F,>49C
Melt/Freeze Pt:M.P/F.P Text:ND
Decomp Temp:Decomp Text:ND
Vapor Pres:ND
Vapor Density:ND
Spec Gravity:1.0
pH:ND
Viscosity:ND
Evaporation Rate & Reference:<1 (N-BUTYL ACETATE=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:BLACK COLOR, PERTOLEUM ODOR.
Percent Volatiles by Volume:ND
Corrosion Rate:ND
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, OXIDIZERS AND POISONS.
Stability Condition to Avoid:KEEP AWAY FROM HEAT OR OPEN FLAMES.
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF MATERIAL IN COMPLIANCE WITH LOCAL,
STATE AND FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
=======================================================
Product ID: ANCO-OX 1095
Cage: 24654
Box: 4507
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 24654
Box: 4507
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: EYES/SKIN: MAY CAUSE IRRITATION. INHALATION: MAY CAUSE
IRRITATION TO THE MUCOUS MEMBRANES. INGESTION: MAY CAUSE IRRITATION TO THE
MUCOUS MEMBRANES AND STOMACH.
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: EYES: FLUSH EYES WITH CLEAN WATER FOR AT LEAST 15 MINUTES. IF
IRRITATION PESISTS, SEEK MEDICAL ATTENTION. SKIN: FLUSH CONTACTED AREA WITH
WATER. INHALATION: REMOVE TO FRESH AIR. INGESTION: DRINK A LAR GE AMOUNT OF
WATER. IF DISCOMFORT PERSISTS, SEEK MEDICAL ATTENTION.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: DILUTE WITH WATER AND FLUSH TO WASTE WITH EXCESS
WATER.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS FOR LIQUID AND SOLID WASTES.
Handling And Storage Precautions: PROTECT CONTAINERS FROM EXTREME TEMPERATURE
CONDITIONS. AVOID CONTACT WITH OXIDIZERS.
Other Precautions: HANDLE WITH CARE. AVOID EYE AND SKIN CONTACT.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: NONE
Extinguishing Media: WATER FOG, FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures: USE NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: NONE.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NOT REQUIRED UNDER NORMAL HANDLING CONDITIONS. USE
NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN (FP N).
Ventilation: MECHANICAL (GENERAL): ACCEPTABLE.
Other Protective Equipment: COVERALLS OR RUBBER APRON TO PREVENT CONTAMINATION
OF CLOTHING.
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: SPEC GRAV: 1.09-1.11 (H2O=1).
=======================================================
Physical/Chemical Properties
=======================================================
HCC: N1
B.P. Text: 212F,100C
Vapor Pres: LIKE WATER
Vapor Density: LIKE WATER
Spec Gravity: SUPDAT
Solubility in Water: COMPLETE
Appearance and Odor: DARK BROWN LIQUID; SLIGHT AROMATIC ODOR.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Materials To Avoid: AVOID CONTACT WITH OXIDIZING MATERIALS.
Hazardous Decomposition Products: THERMAL DECOMPOSITION MAY YIELD OXIDES OF
CARBON AND SULFUR (SOX).
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: ANCO-OX 1095
Cage: 24654
Company Name: ANDERSON CHEMICAL CO INC
Street: 1840 WATERVILLE RD
PO Box: 4507
Zipcode: 31213
Label Required IND: Y
Date Of Label Review: 11/08/1994
Status Code: C
Label Date: 11/08/1994
Origination Code: G
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE: EYES/SKIN: MAY CAUSE IRRITATION. INHALATION: MAY
CAUSE IRRITATION TO THE MUCOUS MEMBRANES. INGESTION: MAY CAUSE IRRITATION TO
THE MUCOUS MEMBRANES AND STOMACH. CHRONIC: NONE LISTED BY MANUFACTU RER.
=======================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:UNLEADED GASOLINE
Preparer's Name:KEITH W. BUNSELMEYER
CAGE:50848
CAGE:50848
CAGE:8P890
============= Composition/Information on Ingredients =============
Ingred Name:GASOLINE (MIXTURE)
CAS:8006-61-9
RTECS #:LX3300000
Fraction by Wt: 85-100%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:300 PPM/500 STEL
ACGIH TLV:300 PPM/500STEL;9293
Ingred Name:METHYL TERT-BUTYL ETHER (SARA III)
CAS:1634-04-4
RTECS #:KN5250000
Fraction by Wt: 0-15%
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:BENZENE (SARA III)
CAS:71-43-2
RTECS #:CY1400000
Fraction by Wt: UP 2%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1PPM/5STEL;1910.1028
ACGIH TLV:10 PPM; A2; 9293
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: UP 10%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: UP 10%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO
Health Hazards Acute and Chronic:CHRONIC: INHALATION-NERVOUS SYSTEM,
KIDNEY, LIVER & BLOOD DISORDERS, INCLUDING ANEMIA & LUKEMIA.
SKIN-DERMATITIS. ACUTE: INHALATION- RESPIRATORY IRRITATION, CENTRAL
NERVOUS SYSTEM DEPRESSION. SKIN-IRR ITATION. EYES-IRRITATION.
INGESTION-ASPIRATION HAZARD, PULMONARY EDEMA, CENTRAL NERVOUS
SYSTEM DEPRESSION.
Explanation of Carcinogenicity:OSHA REQUIRES LABEL: DANGER, CONTAINS
BENZENE, CANCER HAZARD.
Effects of Overexposure:INHALATION-HEADACHE, NAUSEA, DROWSINESS,
BREATHLESSNESS, FATIGUE, CONVULSION & LOSS OF CONSCIOUSNESS.
INGESTION-HEADACHE, NAUSEA, DROWSINESS, FATIGUE, PNEUMONITIS,
CONVULSION AND LOSS OF CONSCIOUSNESS .
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR 15 MINUTES. SKIN: WASH EXPOSED
AREA WITH SOAP AND WATER. INGESTION: DO NOT INDUCE VOMITING. MAY
CAUSE CHEMICAL PNEUMONITIS. CALL A PHYSICIAN. INHALATION: SHOULD
SYMPTOMS NOT ED UNDER EXPOSURE OCCUR, REMOVE TO FRESHAIR. IF NOT
BREATHING, GIVE ARTIFICIAL RESPIRATION. (REMOVE GASOLINE-SOAKED
CLOTHING)
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:-45F,-43C
Autoignition Temp:Autoignition Temp Text:536F
Lower Limits:1.4 %
Upper Limits:7.6 %
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, OR FOAM. WATER STREAM
MAY SPREAD FIRE, USE WTAER SPRAY ONLY TO COOL FIRE EXPOSED
CONTAINER
Fire Fighting Procedures:IF LEAK OR SPILL HAS NOT IGNITED, USE WATER
SPRAY TO DISPERSE THE VAPORS.
Unusual Fire/Explosion Hazard:CAN FORM FLAMMABLE MIXTURES WITH AIR &
FLASH AT ROOM TEMP. EXPLOSION HAZARD IN FIRE SITUATION. VAPORS
HEAVIER THAN AIR & MAY TRAVEL SOME DISTANCE & FLASH BACK.
================== Accidental Release Measures ==================
Spill Release Procedures:NOTIFY EMERGENCY RESPONSE PERSONNEL. EVCUATE
AREA & REMOVE IGNITION SOURCES. BUILD DIKE TO CONTAIN FLOW. REMOVE
FREE LIQUID, DO NOT FLUSH TO SEWER OR OPEN WATER. PUCK UP WITH
INERT ABSORBENT AND PLACE IN CLOSED CONTAINER FOR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE WITH STRONG OXIDIZERS.
STORE AS OSHA IB FLAMMABLE LIQUID.
Other Precautions:WARNING! FLAMMABLE LIQUID AND VAPOR. HARMFUL IF
INHALED & MAY CAUSE DELAYED LUNJ INJURY. ASPIRATION HAZARD IF
SWALLOWED. CANCER HAZARD - CONTAINS BENZENE. KEEP AWAY FROM HEAT,
SPARKS AND FLAMES. AVOID BREATHING VAPORS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:UP TO 10 PPM BENZENE, HALF-MASK ORGANIC VAPOR
RESPIRATOR. UP TO 50 PPM BENZENE, FULL-FACE ORGANIC VAPOR
RESPIRATOR OR FULL-FACE SUPPLIED AIR RESPIRATOR. GREATER THAN 50
PPM BENZENE, SELF-CONTAINED BRE ATHING APPARATUS WITH POSITIVE
PRESSURE.
Ventilation:MAINTAIN LOCAL OR DILUTION VENTILATION TO KEEP AIR
CONCENTRATION BELOW 300 PPM GASOLINE AND 1 PPM BENZENE.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
AVOID CONTACT WITY EYES, SKIN AND CLOTHING.
================== Physical/Chemical Properties ==================
HCC:F1
Boiling Pt:B.P. Text:78.0F,25.6C
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Decomp Temp:Decomp Text:N.A.
Vapor Pres:7-14 MMHG
Vapor Density:3 - 4.0
Spec Gravity:0.7 - .76
pH:N.A.
Viscosity:N.A.
Evaporation Rate & Reference:1.5 X SLOWER ETHYL ETHER
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR TO RED LIQUID
Percent Volatiles by Volume:100 %
Corrosion Rate:N.A.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Stability Condition to Avoid:HEAT, SPARKS, FLAME AND OTHER SOURCES OF
IGNITION.
Hazardous Decomposition Products:INCOMPLETE COMBUSTION CAN YIELD CARBON
MONOXIDE AND VARIOUS HYDROCARBONS.
==================== Disposal Considerations ====================
Waste Disposal Methods:UTILIZE LICENSED WSTE DISPOSAL COMPANY. CONSIDER
RECYCLING OR INCINERATION. UTILIZE PERMITTED HAZARDOUS WASTE
DISPOSAL SITE OR INDUSTRIAL WASTE DISPOSAL SITE AS APPROPIATE.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:SW-612
CAGE:ESABB
CAGE:ESABB
============= Composition/Information on Ingredients =============
Ingred Name:SILICON
CAS:7440-21-3
RTECS #:VW0400000
OSHA PEL:5 MG/M3
ACGIH TLV:10 MG/CUM
Ingred Name:TITANIUM DIOXIDE, TIO2 (SUSPECTED ANIMAL CARCINOGEN, IARC
GROUP 3) *95-2*
CAS:13463-67-7
RTECS #:XR2275000
OSHA PEL:15 MG/CUM
ACGIH TLV:10 MG/CUM (DUST)
Ingred Name:ALUMINUM OXIDE, BAUXITE, ALUMINA, DIALUMINUM TRIOXIDE
CAS:1344-28-1
RTECS #:BD1200000
OSHA PEL:5 MG/CUM
ACGIH TLV:10 MG/CUM
Ingred Name:CALCIUM CARBONATE, DOMOLITE, LIMESTONE, WHITING
CAS:1317-65-3
RTECS #:EV9580000
OSHA PEL:5 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:SODIUM METASILICATE; SODIUM SILICATE; WATER GLASS; DISODIUM
SALT SILIC ACID
CAS:6834-92-0
RTECS #:VV9275000
OSHA PEL:5 MG/M3
ACGIH TLV:10
Ingred Name:SILICIC ACID, DIPOTASSIUM SALT
CAS:10006-28-7
OSHA PEL:5 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:IRON *95-2*
CAS:7439-89-6
RTECS #:NO4565500
OSHA PEL:10 MG/M3
ACGIH TLV:5 MG/M3
Ingred Name:MANGANESE, MN COMPOUNDS
CAS:7439-96-5
RTECS #:OO9275000
Fraction by Wt: 1.5-2%
OSHA PEL:5 MG/CUM
ACGIH TLV:5 MG/CUM (DUST)
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ELECTRIC SHOCK CAN KILL YOU. ARC RAYS
CAN INJURE EYES & BURN SKIN. NOISE CAN DAMAGE HEARING. OVEREXPOSURE
TO GASES/FUMES/DUST MAY CAUSE IRRITATION TO EYES/LUNGS/NOSE &
THROAT. WELDING TOXIC GASES MAY CAUSE PULMONARY EDEMA,
ASPHYXIATION, IRRITATION, REDUCED LUNG FUNCTION/DISEASE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:WELDING GASES/FUMES/DUST IRRITATION, WATER
EYES, HADACHE, DIZZINESS, DIFFICULTY BREATHING, COUGHING, CHEST
PAIN.
Medical Cond Aggravated by Exposure:INDIVIDUALS W/ALLERGIES/IMPAIRED
RESPIRATORY FUNCTION.
======================= First Aid Measures =======================
First Aid:INHALATION: GIVE OXYGEN IF NEEDED. FOR ELECTRIC SHOCK
DISCONNECT & TURN OFF THE POWER. IF NOT BREATHING GIVE CPR,
PERFERABLY MOUTH-TO-MOUTH. SKIN: FOR ARC BURN APPLY COLD, CLEAN
COMPRESSES. OBTAIN MED ICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Extinguishing Media:USE THE EXTINGUISHING MEDIA RECOMMENDED FOR THE
BURNING MATERIALS & FIRE SITUATION.
Unusual Fire/Explosion Hazard:ONLY THE PACKAGING FOR THIS PRODUCT WILL
BURN. WELDING ARCS & SPARKS CAN IGNITE COMBUSTIBLE & FLAMMABLE
MATERIALS.
======================Handling and Storage ======================
Handling and Storage Precautions:TRAIN WELDER NOT TO TOUCH WE
ELECTRICAL PARTS & TO INSULATE, FROM WORK & GROUND.
Other Precautions:TRAIN WELDER TO KEEP HEAD OUT OF THE FUMES.
COMPOSITION & QUANTITY OF THE FUMES & GASES CAN BE DETERMINED FROM
A SAMPLE FROM INSIDE THE WELDER'S HELMET/IN THE BREATHING ZONE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE RESPIRABLE FUME RESPIRATOR/AIR SUPPLED
RESPIRATOR WHEN WELDING IN CONFINED SPACES/WHERE LOCAL
EXHAUST/VENTILATION DOESN'T KEEP EXPOSURE < TLV.
Ventilation:LOCAL EXHAUST AT THE ARC/BOTH, TO KEEP THE FUMES & GASES
<TLV IN BREATHING ZONE & GENERAL AREA.
PROTECTORS, APRONS, HATS, SHOULDER PROTECTION, AS WELL AS DARK
CLOTHING.
Supplemental Safety and Health
AS SHIPPED, PRODUCT IS NONFLAMMABLE/NONEXPLOSIVE/NONREACTIVE & NON
HAZARDOUS. THE COMPOSITION & QUANTITY OF FUMES/GASES DEPENDS ON
METAL BEING WELDED, PROCESS, PROCEDURES, ELECTRODES USED, COATING,
PO SITION OF WELDERS HEAD W/THE PLUME & ASWELL AS THE PRESSURE OF
CONTAMINANTS IN THE ATMOSPHERE.
================== Physical/Chemical Properties ==================
Appearance and Odor:SOLID FLUX COATED MILD STEEL CORE WIRE W/NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
(SEE SUPP)
Stability Condition to Avoid:(SEE SUPP)
Hazardous Decomposition Products:COMPLEX OF OXIDES FLUORIDES, CO, CO2,
OZONE, NITRO OXIDES. (SEE SUPP)
==================== Disposal Considerations ====================
Waste Disposal Methods:PREVENT FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT, RESIDUE IN DISPOSABLE
CONTAINER/LINER IN AN ENVIRONMENTALLY ACCEPTABLE MANNER
IAW/FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:DEEP BASE COLORS SEMI-GLOSS ACCENT BASE, W25006
CAGE:FO133
CAGE:97903
CAGE:FO133
============= Composition/Information on Ingredients =============
Ingred Name:WATER. VAP DENS:LTR/AIR.
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 55%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ACRYLIC RESIN. VAP DENS:HVR/AIR.
Fraction by Wt: 25%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CLAY (KAOLIN); (ALUMINUM SILICATE). VAP DENS:HVR/AIR.
CAS:1332-58-7
RTECS #:GF1670500
Fraction by Wt: 5%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:2 MG/M3 TDUST
Ingred Name:ETHYLENE GLYCOL (SARA III). VP:0.1 @ 68F. LEL:3.2%. VAP
DENS:HVR/AIR.
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: <5%
OSHA PEL:50 PPM (MFR)
ACGIH TLV:50 PPM, VAPOR, C
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE). VAP DENS:HVR/AIR.
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: <5%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:PROPIONIC ACID, 2-METHYL-, MONOESTER W/2,2,4-TRIMETHYL-1,
3-PENTANEDIOL; (2,2,4 TRIMETHYLPENTANEDIOL-1, (ING 7)
CAS:25265-77-4
RTECS #:UF6000000
Fraction by Wt: <5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ING 6:3 MONOISOBUTYRATE). VP:1 @ 188F. VAP DENS:HVR/AIR.
LEL:0.62%.
RTECS #:9999999ZZ
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:AMMONIUM HYDROXIDE; (AQUA AMMONIA)(SARA III). VP:560 @
68F. VAP DENS:LTR/AIR. LEL:16%.
CAS:1336-21-6
RTECS #:BQ9625000
Fraction by Wt: <1%
OSHA PEL:50 PPM (MFR)
ACGIH TLV:25 PPM (MFR)
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:VOLATILE ORGANIC COMPONENT (LESS WATER): 171.9 G/L.
RTECS #:9999999VO
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPDAT:VAP. WHEN USED IN CONFINED AREAS, WEAR NIOSH/MSHA
APPRVD AIR SUPPLY RESPS/HOODS. USE NIOSH/MSHA APPRVD (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10:RESPS WHEN FLAME CUTTING, WELDING, BRAZING & SANDING
MATL COATED W/THIS PROD. FOLLOW RESP MFR'S (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11:DIRECTIONS FOR RESPIRATOR USE.
RTECS #:9999999ZZ
Ingred Name:VENT:STDS IN MIXING, APPLICATION & CURING AREAS & TO REMOVE
SANDING DUSTS OF DRIED COATING & DECOMP PROD DURING (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13:WELDING & FLAME CUTTING ON SURFACES COATED W/THIS
PRODUCT.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL:IRRITATION OF RESPIRATORY
TRACT; MAY AFFECT BRAIN OR NERVOUS SYSTEM CAUSING DIZZINESS,
HEADACHE, NAUSEA. EYE/SKIN CONTACT:CAUSES IRRITATION. INGEST:CAN
CAUSE STOMACH &/OR INTESTINAL IRRITA TION, NAUSEA, VOMITING &
DIARRHEA. ASPIRATION OF VOMITUS CAN CAUSE CHEMICAL PNEUMONITIS,
WHICH CAN BE (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:FATAL. CHRONIC:PROLONGED OR REPEATED
BREATHING OF SPRAY MIST &/OR SANDING DUST OVER A PERIOD OF YEARS
MAY CAUSE DUST DISEASE OF THE LUNGS.
Medical Cond Aggravated by Exposure:NONE WHEN USED I/A/W SAFE HANDLING
& USE INFORMATION.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. EYES:FLUSH W/LARGE AMOUNTS OF
WATER FOR AT LEAST 15 MINUTES. GET MEDICAL ASSISTANCE. SKIN:REMOVE
W/SOAP & WATER. REMOVE SOILED CLOTHING. INGEST:DRINK 1-2 GLASSES OF
WATER. D O NOT INDUCE VOMITING. CONSULT MD IMMEDIATELY. TREAT
SYMPTOMATICALLY. NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS
PERSON.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:SEE INGS
Extinguishing Media:IN CASE OF FIRE, USE CO*2, DRY CHEMICAL, FOAM OR
OTHER NFPA APPROVED METHOD FOR TREATING A CLASS B FIRE.
Fire Fighting Procedures:USE NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP .
SUMMON PROFESSIONAL FIREFIGHTERS. WATER SPRAY MAY BE INEFT. IF
WATER IS USED, FOG NOZZ ARE PREF. IF(SUPDAT)
Unusual Fire/Explosion Hazard:DUE TO PRESS BUILD-UP, CLSD CNTNRS EXPOS
TO EXTREME HEAT MAY EXPLODE. AFTER WATER EVAPS, REMAINING MATL WILL
BURN. DURING EMER CNDTNS, OVEREXP TO DECOMP(SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:WASH W/WATER. BEFORE ATTEMPTING CLEAN-UP,
REFER TO HAZARD INFORMATION IN OTHER SECTIONS OF THIS MSDS. CONTAIN
SPILLED MATERIAL & REMOVE W/INERT ABSORBENT. STORE IN CLOSED
CONTAINERS UNTIL PROPERLY DIS POSED OF.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE <110F. KEEP FROM FREEZING. KEEP
CONTAINER CLOSED WHEN NOT IN USE. DO NOT REUSE EMPTY CONTAINERS.
KEEP OUT OF REACH OF CHILDREN.
Other Precautions:DO NOT GET IN EYES. USE ONLY W/ADEQUATE VENTILATION.
DO NOT BREATHE VAPORS, SPRAY MIST OR SANDING DUST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHEN SPRAY APPLIED IN OUTDOOR/OPEN AREAS
W/UNRESTRICTED VENT & DURING SANDING/GRINDING OPERATIONS, USE
NIOSH/MSHA APPRVD MECH FILTER RESP TO REMOVE SOLID AIRBORNE
PARTICLES OF OVERSPRAY & SANDING DUST . WHEN USED IN RESTRICTED
AREAS,(SUPDAT)
Ventilation:PROVIDE GEN DILUTION/LOC EXHST VENT IN VOL & PATTERN TO
KEEP AIR CONTAM CONC BELOW CURRENT APPLIC SAFETY & HLTH (ING 13)
Other Protective Equipment:NOT REQUIRED.
Work Hygienic Practices:REMOVE & WASH SOILED CLOTHING BEFORE REUSE.
WASH HANDS BEFORE EATING, SMOKING OR USING THE WASHROOM.
Supplemental Safety and Health
FIRE FIGHT PROC:EXPOS TO FIRE/EXTREME HEAT, WATER SHOULD BE USED TO
COOL CLSD CNTNRS & PVNT PRESS BUILD-UP/POSS AUTO-IGNIT. EXPLO
HAZ:PRODS MAY CAUSE HLTH HAZ. SYMPS MAY NOT BE IMMED APPARENT.
OBTAIN MED ATTN. RESP PROT:WEAR NIOSH/MSHA APPRVD CHEM/MECH
FILTERS DESIGNED TO REMOVE COMBINATION OF PARTICULATES & (ING 10)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>212F,>100C
Vapor Pres:SEE INGS
Vapor Density:SEE INGS
Spec Gravity:1.09
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:69
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT W/MATERIALS THAT ARE UNSTABLE W/WATER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:MAY CAUSE HAZ FUMES WHEN HEATED TO
DECOMP. FUMES MAY CONTAIN CARBON MONOXIDE, CARBON DIOXIDE & OXIDES
OF INGS LISTED.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF I/A/W LOCAL, STATE & FEDERAL
REGULATIONS. INCINERATE ONLY IN APPROVED FACILITY. DO NOT
INCINERATE CLOSED CONTAINERS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ARCTON 11
CAGE:GO644
CAGE:GO644
============= Composition/Information on Ingredients =============
Ingred Name:FLUOROTRICHLOROMETHANE, FREON 11, TRICHLOROFLUOROMETHANE,
TRICHLOROMONOFLUOROMETHANE
CAS:75-69-4
RTECS #:PB6125000
Fraction by Wt: 100%
Other REC Limits:1000 PPM MSHA
OSHA PEL:1000 PPM
ACGIH TLV:C 5600 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ozone Depleting Chemical:1
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INGESTION: SLIGHTLY TOXIC. EYES:
REVERSIBLE IRRITATIVE SYMPTOMS. SKIN: REVERSIBLE DISCOMFORT;
REPEATED/PROLONGED CONTACT CAN CAUSE IRRITATION. IN SUSCEPTIBLE
INDIVIDUALS, CARDIAC SENSITIZATION TO CIRC ULATING EPINEPHRINE-LIKE
COMPOUNDS CAN RESULT IN SUDDEN, FATAL CARDIAC ARRHYTHMIAS. LIQUID
REMOVES NATURAL SKIN OILS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:DISCOMFORT, IRRITATION, GIDDINESS, WEAKNESS,
DIZZINESS, NAUSEA, UNCONSCIOUSNESS, SKIN FREEZE, BURNS, FISSURING
======================= First Aid Measures =======================
First Aid:SKIN: WASH OFF W/PLENTY OF SOAP & WATER. EYES: IMMEDIATELY
FLUSH W/PLENTY OF WATER FOR 15 MINS. INHALATION: REMOVE TO FRESH
AIR. GIVE CPR/OXYGEN IF NECESSARY. OBTAIN MEDICAL ATTENTION IN ALL
CASES. NO TE TO PHYSICIAN: DON'T GIVE ADRENALINE/SIMILAR
SYMPATHOMIMETIC DRUGS. DON'T ALLOW TO EXERCISE VIGOROUSLY UNTIL 24
HOURS FOLLOWING EXPOSURE.
===================== Fire Fighting Measures =====================
Lower Limits:NONE
Upper Limits:NONE
Fire Fighting Procedures:USE WATER TO COOL FIRE EXPOSED CYLINDERS/OTHER
CONTAINERS. USE SELF CONTAINED BREATHING APPARATUS W/FULL FACEPIECE
& PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:HEAVY VAPORS CAN SUFFOCATE. HIGHLY TOXIC
DECOMPOSITION PRODUCTS.
================== Accidental Release Measures ==================
Spill Release Procedures:RECOVER ANY LIQUID & VENTILATE AREA. USE SELF
CONTAINED BREATHING APPARATUS TO AVOID SUFFOCATION. PROTECT AGAINST
FROSTBITE FROM EVAPORATING LIQUID.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL AREA W/GOOD
VENTILATION. KEEP VAPORS AWAY FROM HIGH TEMP SURFACE TO AVOID TOXIC
& CORROSIVE DECOMPOSITION PRODUCTS.
Other Precautions:ENFORCE NO SMOKING RULES IN AREAS OF USE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOR HIGH CONCENTRATIONS & OXYGEN-DEFICIENT
ATMOSPHERES, USE POSITIVE PRESSURE AIR-SUPPLIED RESPIRATOR.
Ventilation:VENTILATE LOW-LYING AREAS SUCH AS SUMPS/PITS WHERE DENSE
VAPORS MAY COLLECT. PROVIDE LOCAL EXHAUST IF TLV IS EXCEEDED.
Other Protective Equipment:IMPERVIOUS APRON, ARM COVERS/A FULL BODY
SUIT, EYE WASH STATION, SAFETY SHOWER
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:74.8F
Vapor Density:4.7
pH:7
Solubility in Water:0.11%
Appearance and Odor:COLORLESS, NEARLY ODORLESS LIQUEFIED GAS
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
SODIUM, POTASSIUM, BARIUM METAL, ALUMINUM, ZINC & MAGNESIUM
Stability Condition to Avoid:HIGH TEMPERATURES
Hazardous Decomposition Products:HALOGENS, HALOGEN ACIDS, TRACES OF
CARBONYL HALIDES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCARDED PRODUCT IS A HAZARDOUS WASTE NUMBER
UN121. DISPOSE OF IN ACCORDANCE W/LOCAL, STATE & FEDERAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ABC DRY CHEMICAL
CAGE:DO025
CAGE:DO025
CAGE:54905
============= Composition/Information on Ingredients =============
Ingred Name:AMMONIUM PHOSPHATE MONOBASIC
CAS:7722-76-1
Other REC Limits:NONE SPECIFIED
Ingred Name:MICA - SILICATES (< 1% CRYSTALLINE SILICA)
CAS:12001-26-2
RTECS #:VV8760000
Other REC Limits:NONE SPECIFIED
OSHA PEL:20 MPPCF
ACGIH TLV:3 MG/M3 RDUST; 9293
Ingred Name:SILICA GEL
CAS:112945-52-5
RTECS #:VV7310000
Other REC Limits:NONE SPECIFIED
OSHA PEL:6 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:AMMONIUM SULFATE (SOLUTION) (SARA III)
CAS:7783-20-2
RTECS #:BS4500000
Other REC Limits:NONE SPECIFIED
Ingred Name:METHYL HYDROGEN POLYSILOXANE
CAS:63148-57-2
Other REC Limits:NONE SPECIFIED
Ingred Name:YELLOW PIGMENT
CAS:5468-75-7
Other REC Limits:NONE SPECIFIED
Ingred Name:MANUFACTURER DID NOT SPECIFY THE GAS USED IN THE FIRE
EXTINGUISHER WITH THE DRY CHEMICAL.
RTECS #:9999999ZZ
Other REC Limits:NONE SPECIFIED
OSHA PEL:NOT SPECIFIED
ACGIH TLV:NOT SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE, SKIN & RESPIRATORY TRACT
IRRITATION. HARMFUL IF SWALLOWED. MAY CAUSE SORE THROAT, ABDOMINAL
PAIN, NAUSEA, VOMITING.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:EYE, SKIN & RESPIRATORY TRACT IRRITATION.
HARMFUL IF SWALLOWED. MAY CAUSE SORE THROAT, ABDOMINAL PAIN,
NAUSEA, VOMITING.
Medical Cond Aggravated by Exposure:NONE KNOWN
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH RUNNING WATER FOR 15 MINUTES WHILE HOLDING
EYELIDS OPEN. GET MEDICAL ATTENTION IMMEDIATELY. SKIN: WASH WITH
SOAP AND WATER. REMOVE CONTAMINATED CLOTHING. GET MEDICAL ADVICE.
INHALATIO N: REMOVE TO FRESH AIR. GIVE MOUTH-TO-MOUTH RESUSCITATION
IF NOT BREATHING. GET MEDICAL ATTENTION. INGESTION: DO NOT INDUCE
VOMITING. RINSE MOUTH & DRINK LARGE AMOUNTS OF WATER. GET MEDICAL
ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:NONE. THIS MATERIAL IS AN EXTINGUISHING AGENT.
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN AND SWEEP UP.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN CLOSED, MOISTURE-FREE
CONTAINERS IN A COOL, DRY LOCATION. AVOID UNNECESSARY DUSTINESS.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR A NIOSH/MSHA APPROVED DUST RESPIRATOR WHEN
TLV IS EXCEEDED. NUISANCE DUST (TOTAL) 15 MG/M3. DUST RESPIRATOR
RECOMMENDED WHENEVER AIRBORNE DUST IS PRESENT.
Ventilation:LOCAL AND MECHANICAL(GENERAL) EXHAUST TO PROVIDE ADEQUATE
VENTILATION IS RECOMMENDED.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:USE GOOD PERSONAL HYGIENE AND GOOD HOUSEKEEPING
PRACTICES.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:G3
Spec Gravity:0.85
pH:4.4
Solubility in Water:H2O REPELLANT COATED
Appearance and Odor:YELLOW POWDER. NO CHARACTERISTIC ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ALKALIES AND MAGNESIUM METAL
Hazardous Decomposition Products:CARBON MONOXIDE, AMMONIA AND OXIDES OF
NITROGEN
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL SHOULD BE MADE IN ACCORDANCE WITH ALL
APPLICABLE FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
Subsets and Splits
No saved queries yet
Save your SQL queries to embed, download, and access them later. Queries will appear here once saved.