text
stringlengths 542
18.7k
| label
int64 0
1
| label_text
stringclasses 2
values |
|---|---|---|
===================== Product Identification =====================
Product ID:FOAMGLAS INSULATION
Preparer's Name:H J PATRICK
CAGE:FO807
CAGE:08869
CAGE:FO807
============= Composition/Information on Ingredients =============
Ingred Name:HYDROGEN SULFIDE (SARA 302/313) (CERCLA)
CAS:7783-06-4
RTECS #:MX1225000
Fraction by Wt: 2-4%
OSHA PEL:20 PPM, C
ACGIH TLV:10 PPM/15 STEL
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:CARBON MONOXIDE
CAS:630-08-0
RTECS #:FG3500000
Fraction by Wt: 3-10%
OSHA PEL:50 PPM
ACGIH TLV:25 PPM
Ingred Name:GLASS DUST (PNOC)
Fraction by Wt: VARIES
OSHA PEL:15 MG/M3 (MFR)
ACGIH TLV:10 MG/M3 (MFR)
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL: HDCH, NAUS, & DIFFICULTY
BRTHG, DIZZ. SENSE OF SMELL MAY BE FATIGUED OVER TIME. ODOR & IRRIT
EFTS DO NOT OFFER DEPENDABLE WARNING TO WORKERS WHO MAY BE EXPOSED
TO GRADUALLY INCREASING AM TS & THEREFORE BECOME USED TO IT.
EYES:IRRIT & INFLAMM OF MUC MEMB, TEARING, SENSITIVITY TO LIGHT.
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: SKIN: IRRIT/ABRASION FROM GLASS
PARTICLES. INGEST: POSS ABRASION OF MOUTH & THROAT FROM GLASS
PARTICLES. CHRONIC: CHRONIC POISONING RESULTS IN HDCH, INFLAMM OF
EYELIDS & MUC MEMB THAT LINES INNER SURF OF EYELIDS, DIGESTIVE
DISTURB, WT LOSS & GEN WEAK.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/POTABLE WATER FOR AT LEAST 15 MIN, DO NOT
RUB/APPLY PRESS. CONSULT MD/EMER MED SERVICE. SKIN: WASH THORO
W/OUT PRESS. IF IRRIT PERSISTS/SKIN IS BROKEN, CONSULT MD. INHAL:
REMOVE TO FRESH AIR, APPLY ARTIFICIAL RESP IF NEEDED. CALL POISON
CONTROL CENTER, MD/EMER MED SERVICE GIVING CAS NAMES & NUMBERS OF
GASES. INGEST: DO NOT INDUCE VOMITING. CONSULT MD, EMER MED
SERVICE/POISON CENTER.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE WATER, DRY CHEMICAL OR CARBON DIOXIDE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:MAY RELEASE HYDROGEN SULFIDE & CARBON
MONOXIDE GAS WHEN INVOLVED IN FIRE. SML AMTS OF HYDROGEN SULFIDE &
CARBON MONOXIDE RELEASED ARE NOT EXPECTED TO (SUP DAT)
================== Accidental Release Measures ==================
Spill Release Procedures:COLLECT IN SIFT-PROOF CONTAINERS. AVOID
GENERATION OF DUST.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID GENERATION OF DUST. IF STORING
FOR LONG PERIODS, PROTECT INSULATION FROM WEATHER.
Other Precautions:NONE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPRVD NUISANCE DUST MASK WHEN
CUTTING/ABRADING W/ADEQ VENT (6 AIR/CHANGES/HR). NIOSH/MSHA APPRVD
SUPP AIR/SCBA IN POORLY VENT AREAS IS REQUIRED WHEN CRUSHING OF
PROD INSULATION CAUSES PEL OF HYDROGEN SULFIDE & (SUP DAT)
Ventilation:USE LOCAL EXHAUST WHEN CUTTING. USE MECHANICAL VENTILATION
WHEN CRUSHING LARGE VOLUMES.
Other Protective Equipment:NORMAL WORK CLOTHES INCLUDING LONG-SLEEVED
SHIRT. EMERGENCY EYEWASH & DELUGE SHOWER MEETING ANSI DESIGN
CRITERIA .
Work Hygienic Practices:USE GOOD HOUSEKEEPING AND HYGIENE PRACTICES.
Supplemental Safety and Health
SPEC GRAV: 0.11-0.14 (H*2O=1). EXPLO HAZ: CONTRIBUTE TO INTENSITY OF
FIRE. RESP PROT: CARBON MONOXIDE GASES TO BE EXCEEDED.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:1350F,732C
Spec Gravity:SUP DAT
Solubility in Water:INSOLUBLE
Appearance and Odor:BLACK CELLULAR MATERIAL, NO ODOR UNLESS CUT OR
CRUSHED
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN APPROVED LANDFILL IN ACCORDANCE
WITH ALL LOCAL, STATE, AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:HYDROCOTE 1063 SZ PART A
CAGE:FO873
CAGE:98898
CAGE:FO873
============= Composition/Information on Ingredients =============
Ingred Name:EPOXY RESIN. LD50:(ORAL RAT)11.4 G/KG.
CAS:25068-38-6
RTECS #:KC2100000
Ingred Name:PHOSPHOROUS ACID, TRIPHENYL ESTER;(TRIPHENYL PHOSPHITE).
LD50:(ORAL RAT) 1600 MG/KG. BP:680F, 360C. VP:1 @ 155C.
CAS:101-02-0
RTECS #:TH1575000
Fraction by Wt: 1-5%
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENTTS
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN:PROLONGED OR REPEATED EXPOSURE
MAY CAUSE SKIN IRRITATION AND REDNESS. SKIN SENSITIZATION OR
ALLERGIC REACTION MAY OCCUR IN SOME INDIVIDUALS. INHAL:VAPORS MAY
BE IRRITATING TO NOSE & MUCOUS MEMBRA NES. EYE:CONTACT CAN CAUSE
SEVERE IRRITATION, REDNESS, TEARING AND BLURRED VISION.
INGEST:INTAKE CAN (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:CAUSE GASTROINTESTINAL IRRITATION,
NAUSEA, VOMITING, DIARRHEA, HEADACHE AND DROWSINESS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:MOVE FROM EXPOS. IF DFCLTY W/BRTHG, GIVE O*2. IF UNCON,
GIVE ARTF RESP & GET MD IMED. EYE:FLUSH WITH WATER, LIFTING UPPER &
LOWER LIDS OCCASIONALLY FOR 15 MINS. GET MD. SKIN:WASH W/SOAP &
WATER; GET MD IF IRRIT PERSISTS. INGEST:DO NOT INDUCE VOMIT. GIVE
LGE QTYS OF WATER; GET MD IMMED. IF VOMIT OCCURS SPONTANEOUSLY,
KEEP HEAD BELOW HIPS TO PVNT ASPIR OF LIQS INTO LUNGS. DO NOT GIVE
(SUPDAT)
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:383F,195C
Extinguishing Media:CO*2, FOAM, DRY CHEMICAL AND WATER FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
.AT HIGHER TEMPS VAPS CAN CAUSE PRESS BUILD UP IN SEALED CNTNRS.
USE WATER TO COOL CNTNRS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:VAPORS HEAVIER THAN AIR CAN CONCENTRATE,
TRAVEL TO SOURCE OF IGNIT, & FLASH BACK. RESIDUE IN CNTNR CAN
IGNITE EXPLO. ELEC GROUNDING IS NOT REC.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. WEAR APPROPRIATE PROTECTIVE
GEAR, CONTAIN LEAK OR SPILL, SALVAGE, CLEAN UP RESIDUE WITH
ABSORBENT MATERIAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAIERS TIGHTLY SEALED; STORE
IN DRY AND COOL AREA.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHEN AIRBORNE CONC EXCEED TLV CEILINGS OR TWA,
USE NIOSH/MSHA APPROVED RESP FOR LISTED HAZ.CONFINED SPACES, ROOMS
OR TANKS ARE AREAS WHERE CONCERN FOR TLV'S IS ESPECIALLY IMPORTANT.
REFERENCE OSHA REG29 CFR 1910.134 FOR REC RESP PROT.
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:BOOTS & APRON DEPENDING ON OPERATION.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRST AID PROC:ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:SEE ING 2
Vapor Pres:SEE ING 2
Vapor Density:HVR/AIR
Spec Gravity:1.77
Solubility in Water:NIL
Appearance and Odor:WHITE PASTE WITH A MILD ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, STRONG BASES, AMINES, AND MERCAPTANS MAY INITIATE
POLYMERIZATION POSSIBLY HAZARDOUSLY.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CO & CO*2, ALDEHYDES, ACIDS, AND
VARIOUS HYDROCARBONS FROM INCOMPLETE COMBUSTION.
Conditions to Avoid Polymerization:MAY OCCUR IF PRODUCT IS NOT HANDLED
PER INSTRUCTIONS.
==================== Disposal Considerations ====================
Waste Disposal Methods:HANDLE DISPOSAL OF WASTE MATERIAL IN MANNER
WHICH COMPLIES WITH LOCAL, STATE, PROVINCE AND FEDERAL REGULATION.
LANDFILL IF SOLIDIFIED OR INCINERATION AT AGENCY APPROVED
WASTE-DISPOSAL FACILITIES.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:AQUAFORTIS HYDROGEN NITRATE, NX0411
CAGE:DO242
CAGE:DO242
CAGE:0GDF9
============= Composition/Information on Ingredients =============
Ingred Name:NITRIC ACID (SARA III)
CAS:7697-37-2
RTECS #:QU5775000
Fraction by Wt: 63.01%
OSHA PEL:2 PPM/4 STEL
ACGIH TLV:2 PPM/4 STEL; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CAUSES SEVERE BURNS ON CONTACT WITH
ANY BODY TISSUE. INHALATION OF VAPORS OR MISTS CAN CAUSE SEVERE
BURNS TO RESPIRATORY PASSAGES, PNEUMONIA AND PULMONARY EDEMA. CAN
BE FATAL IF INHALED OR SWALLOWED. SYMPTOMS OF LUNG INJURY MAY BE
DELAYED.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:RESPIRATORY CONDITIONS.
======================= First Aid Measures =======================
First Aid:GET MEDICAL ASSISTANCE FOR ALL CASES OF OVEREXPOSURE. SKIN:
IMMEDIATELY FLUSH THOROUGHLY WITH LARGE AMOUNTS OF WATER. EYES;
IMMEDIATELY FLUSH THOROUGHLY WITH WATER FOR AT LEAST 15 MINUTES.
INHALATION: REMOVE TO FRESH AIR; GIVE ARTIFICAL RESPIRATION IF
BREATHING HAS STOPPED. INGEST: DO NOT INDUCE VOMITING; IF
CONSCIOUS, GIVE WATER FREELY AND GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONCOMBUSTIBLE
Extinguishing Media:WATER SPRAY, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:CAN REACT EXPLOSIVELY WITH CERTAIN
REDUCING AGENTS AND COMBUSTIBLES; SUCH AS METAL POWDERS, CARBIDES,
H2S, TURPENTINE.
================== Accidental Release Measures ==================
Spill Release Procedures:DIKE SPILL WITH SAND AND SODA ASH. DILUTE WITH
WATER AND TAKE UP FOR PROPER DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED AND
PROTECTED FROM PHYSICAL DAMAGE. STORE IN A COOL, DRY AREA AWAY FROM
COMBUSTIBLE OR REDUCING MATERIALS.
Other Precautions:DO NOT BREATHE VAPOR OR MIST. DO NOT GET IN EYES, ON
SKIN OR ON CLOTHING. RETAINED RESIDUE MAY MAKE EMPTY CONTAINERS
HAZARDOUS; USE CAUTION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:MATERIAL MUST BE HANDLED OR TRANSFERRED IN AN APPROVED FUME
HOOD OR WITH EQUIVALENT VENTILATION.
Other Protective Equipment:PROT CLTHG (NATURAL RUB, NEOPRENE, PVC/
EQUIVALENT) SHOULD BE WORN WHEN HNDLG MATL. EMER EYEWASH & DELUGE
SHOWER .
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. DO NOT TAKE
INTERNALLY.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:C1
Boiling Pt:B.P. Text:252F,122C
Melt/Freeze Pt:M.P/F.P Text:-29F,-34C
Vapor Pres:62 @ 20 C
Vapor Density:2.5
Spec Gravity:1.41
Solubility in Water:MISCIBLE
Appearance and Odor:COLORLESS LIQUID WITH ACRID ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STEAM, BASES, REDUCING AGENTS, ORGANIC MATERIALS, COMBUSTIBLE MATTER.
Stability Condition to Avoid:STRONG OXIDIZER. AVOID CONTACT WITH ALL
COMBUSTIBLE MATTER.
Hazardous Decomposition Products:NOX.
==================== Disposal Considerations ====================
Waste Disposal Methods:TO BE PERFORMED IN COMPLIANCE WITH ALL CURRENT
LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MX0070/MX0078/MX0080/MX0208 EPSOM SALTS
CAGE:63612
CAGE:63612
============= Composition/Information on Ingredients =============
Ingred Name:MAGNESIUM SULFATE
CAS:10034-99-8
RTECS #:OM4508000
Fraction by Wt: 100%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: IRRITATION TO UPPER
RESPIRATORY PASSAGES.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION.
======================= First Aid Measures =======================
First Aid:SKIN: WASH THOROUGHLY W/SOAP & WATER. EYES: IMMEDIATELY FLUSH
W/WATER FOR 15 MINS. INHALATION: REMOVE TO FRESH AIR. INGESTION: IF
CONSCIOUS, GIVE WATER FREELY. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Flash Point:NONCOMBUSTIBLE
Extinguishing Media:USE ANY SUITABLE FOR ADJACENT MATERIAL.
Fire Fighting Procedures:WEAR SELF CONTAINED BREATHING APPARATUS.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE THE AREA OF ALL UNNECESSARY
PERSONNEL. WEAR PROTECTIVE EQUIPMENT. ELIMINATE ANY IGNITION
SOURCES. CONTAIN THE RELEASE & ELIMINATE ITS SOURCE SAFELY W/OUT
RISK. TAKE UP & CONTAINERIZE FOR PROP ER DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED. STORE AT
CONTROLLED ROOM TEMP.
Other Precautions:DON'T BREATHE DUST. DON'T GET IN EYES. AVOID
PROLONGED/REPEATED SKIN CONTACT. DON'T TAKE INTERNALLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:REQUIRED.
Ventilation:APPROVED FUME HOOD/ADEQUATE VENTILATION.
Other Protective Equipment:EYE WASH & SAFETY EQUIPMENT.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. HANDLING CARE
GENERALLY IN KEEPING W/SAFE LABORATORY PRACTICES IS RECOMMENDED.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Decomp Temp:Decomp Text:2055.2F
Spec Gravity:1.67
Solubility in Water:COMPLETE
Appearance and Odor:WHITE CRYSTALS W/NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:EXTREME HEAT.
Hazardous Decomposition Products:SULFUR OXIDES, TOXIC FUMES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:HFE-71DA 3M NOVEC ENGINEERED FLUID
Resp. Party Other MSDS Num.:ID: 98-0211-9345-7. DOCUMENT:08-0613-3
CAGE:28112
CAGE:28112
============= Composition/Information on Ingredients =============
Ingred Name:1,2-TRANS-DICHLOROETHYLENE
CAS:156-60-5
RTECS #:KV9400000
Minumum % Wt:44.
Maxumum % Wt:46.
Other REC Limits:75 PPM CMRG
OSHA PEL:200 PPM
ACGIH TLV:200 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:METHYL NONAFLU0ROISOBUTYL ETHER
CAS:163702-08-7
Minumum % Wt:26.
Maxumum % Wt:38.
Other REC Limits:750 PPM AIHA
Ingred Name:METHYL NONAFLUOROBUTYL ETHER
CAS:163702-07-6
Minumum % Wt:15.
Maxumum % Wt:27.
Other REC Limits:750 PPM AIHA
Ingred Name:ETHYL ALCOHOL
CAS:64-17-5
RTECS #:KQ6300000
Minumum % Wt:2.4
Maxumum % Wt:3.
OSHA PEL:1900 MG/M3;1000 PPM
ACGIH TLV:1880 MG/M3;1000 PPM
Ingred Name:ISO-PROPYL ALCOHOL
CAS:67-63-0
RTECS #:NT8050000
Minumum % Wt:.1
Maxumum % Wt:.14
OSHA PEL:980 MG/M3;400 PPM
OSHA STEL:500 PPM
ACGIH TLV:983 MG/M3;400 PPM
ACGIH STEL:1230 MG/M3;500 PPM
===================== Hazards Identification =====================
LD50 LC50 Mixture:NOT PROVIDED BY MFR
Health Hazards Acute and Chronic:EYE CONTACT: MODERATE IRRITATION. SKIN
CONTACT: MODERATE IRRITATION. INHALATION: SINGLE OVEREXPOSURE,
ABOVE RECOMMENDED GUIDELINES, MAY CAUSE CENTRAL NERVOUS SYSTEM
DEPRESSION. SWALLOWED: INGESTION IS NOT A LIKELY ROUTE OF EXPOSURE
TO THIS PRODUCT.
Explanation of Carcinogenicity:NOT PROVIDED BY MFR
Effects of Overexposure:EYE CONTACT: IRRITATION, REDNESS, SWELLING,
PAIN, TEARING, AND HAZY VISION. SKIN CONTACT: IRRITATION, REDNESS,
SWELLING, ITCHING, AND DRYNESS. INHALATION: CNS DEPRESSION,
HEADACHE, DIZZINESS, DROWSINE SS, INCOORDINATION, SLOWED REACTION
TIME, SLURRED SPEECH, GIDDINESS AND UNCONSCIOUSNESS. IRRITATION
(UPPER RESPIRATORY): SORENESS OF THE NOSE AND THROAT, COUGHING, AND
SNEEZING.
Medical Cond Aggravated by Exposure:NOT PROVIDED BY MFR
======================= First Aid Measures =======================
First Aid:EYE CONTACT: IMMEDIATELY FLUSH WITH LARGE AMOUNTS OF WATER.
GET IMMEDIATE MEDICAL ATTENTION. SKIN CONTACT: FLUSH WITH LARGE
AMOUNTS OF WATER. IF IRRITATION PERSISTS, GET MEDICAL ATTENTION.
INHALATION : REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE ARTIFICIAL
RESPIRATION. IF BREATHING IS DIFFICULT, GET IMMEDIATE MEDICAL
ATTENTION. SWALLOWED: IF SWALLOWED, DO NOT INDUCE VOMITING. GIVE
VICTIM TWO GLASS ES OF WATER. CALL A PHYSICIAN IMMEDIATELY. NEVER
GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Autoignition Temp:=420.C, 788.F
Lower Limits:5.1 % BY VOL
Upper Limits:12.7% BY VOL
Extinguishing Media:WATER, CARBON DIOXIDE, DRY CHEMICAL, DRY POWDER.
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING, INCLUDING
HELMET, SELF CONTAINED, POSITIVE PRESSURE OR PRESSURE DEMAND
BREATHING APPARATUS, BUNKER COAT AND PANTS, BANDS AROUND ARMS,
WAIST AND LEGS, FACE MASK, AND PROT ECTIVE COVERING FOR EXPOSED
AREAS OF THE HEAD.
Unusual Fire/Explosion Hazard:UNUSUAL REACTION HAZARD: NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:OBSERVE PRECAUTIONS FROM OTHER SECTIONS.
VENTILATE AREA. CONTAIN SPILL. COVER WITH ABSORBENT MATERIAL.
COLLECT SPILLED MATERIAL. CLEAN UP RESIDUE WITH AN APPROPRIATE
ORGANIC SOLVENT. READ AND FOLLOW S AFETY PRECAUTIONS ON THE SOLVENT
LABEL AND MSDS. PLACE IN METAL CONTAINER. SEAL THE CONTAINER. FOR
SPILLS RESULTING IN SIGNIFCANT RELEASE IN A CONFINED AREA, WARN
OTHERS AND LEAVE IMMEDIATELY.
Neutralizing Agent:NOT PROVIDED BY MFR
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM ACIDS, HEAT, PARKS,
OPEN FLAME, OTHER SOURCES OF IGNITION.. KEEP CONTAINER CLOSED WHEN
NOT IN USE AND IN WELL-VENTILATED AREA. AS A GENERAL PRECAUTION,
AVOID EXPOSURE TO TEMPERATURES A BOVE THE BOILING POINT (40C) AND
BELOW THE CRITICAL SOLUTION TEMPERATURE (-29C).
Other Precautions:PREVENTION OF ACCIDENTAL INGESTION: DO NOT EAT,
DRINK, OR SMOKE WHEN USING THIS PRODUCT. WASH EXPOSED AREAS
THORORGHLY WITH SOAP AND WATER. NOT AN EXPECTED ROUTE OF EXPOSURE.
SMOKING WHILE USING THIS PRODUCT CAN RESULT IN CONTAMINATION OF
TOBACCO AND/OR SMOKE AND LEAD TO FORMATION OF HAZARDOUS DECO
MPOSITION PRODUCTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AVOID BREATHING OF VAPORS, MISTS OR SPRAY.
IFVENTILATION IS NOT ADEQUATE SELECT ONE OF FOLLOWING NIOSH
APPROVED RESPIRATORS BASED ON AIRBORNE CONCENTRATION OF
CONTAMINANTS AND IN ACCORDANCE WITH OSHA REGULATIONS: HALF-MASK
ORGANIC VAPOR RESPIRATOR, FULL-FACE ORGANIC VAPOR RESPIRATOR. IF
THERMAL DECOMPOSITION OCCURS, USE SUPPLIED AIR RESPIRATORY
PROTECTION.
Ventilation:USE IN A WELL-VENTILATED AREA. PROVIDE SUFFICIENT
VENTILATION TO MAINTAIN EMISSIONS BELOW RECOMMENDED LIMITS.
VINYL ALCOHOL RECOMMENDED
SHIELDS.
Other Protective Equipment:AVOID SKIN CONTACT. WEAR AN APRON.
Work Hygienic Practices:DO NOT EAT, DRINK OR SMOKE WHEN USING THIS
PRODUCT. WASH EXPOSED AREAS THOROUGHLY WITH SOAP AND WATER.
Supplemental Safety and Health
AVOID EXPOSING MATERIAL TO EXTREME CONDITIONS OF HEAT (>150C , WELDING,
OPEN FLAME). ID NUMBER / U.P.C.: 98-0211-9344-0; 98-0211-9346-5;
98-0211-9348-1; 00-51135-11173-4; 00-51135-11175-8; 00-51135-11
177-2; 98-0211-9345-7; 98-0211-9347-3; 98-0212-1171-3;
00-51135-11174-1; 00-51135-11176-5; 00-51135-63035-8.
================== Physical/Chemical Properties ==================
HCC:T6
Boiling Pt:=40.C, 104.F
Decomp Temp:Decomp Text:NOT PROVIDED BY MFR
Vapor Pres:413 MMHG @ 25 DEG C
Vapor Density:4.7 (AIR=1
Spec Gravity:CA. 1.33 G/ML
VOC Pounds/Gallon:654
Viscosity:< 0.45 CENTIPOISE
Evaporation Rate & Reference:N/D
Solubility in Water:SLIGHT
Appearance and Odor:CLEAR, COLORLESS LIQUID, SLIGHT ODOR.
Percent Volatiles by Volume:100
Corrosion Rate:NOT PROVIDED BY MFR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG BASES, STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:AVOID TEMPERATURES ABOVE THE BOILING
POINT.
Hazardous Decomposition Products:CARBON MONOXIDE AND CARBON DIOXIDE,
HYDROGEN CHLORIDE, HYDROGEN FLUORIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
=================== Toxicological Information===================
Toxicological Information:THE TOXICITY INFORMATION ON
TRANS-DICHLOEOETHYLENE HAS BEEN LIMITED TO STUDIES OF QUESTIONABLE
QUALITY. THESE STUDIES SUGGESTED LIVER AND KIDNEY TOXICITY AT
ELEVATED CONCENTRATIONS. RECENTLY A 90-DAYINHALATION STUDY WAS
CONDUCTED TO CLARIFY THE TOXICITY OF TRANS-DICHLOROETHYLENE. NO
ADVERSE EFFECTS WERE SEEN IN THIS STUDY WHICH HAD A HIGH DOSE OF
4000 PPM. T0XICITY DATA FOR METHYLISOPERFLUOROBUTY L AND
METHYLPERFLUOROBUTYL COMPONENTS: ACUTE INHALATION LETHAL
CONCENTRATION: >100,000 PPM (4 HR). ORAL TOXICITY: PRACTICALLY
NON-TOXIC (LD50 > 5G/KG IN ALBANO RAT). DEVELOPMENTAL TOXICITY: NO
ABNORMA L (CONTD. SEE "TRANSPORT")
===================== Ecological Information =====================
Ecological:MIXTURE OF METHYL NONAFLUOROBUTYLETHER AND METHYL
NONAFLUOROISOBUTYLETHER HAS A ZERO OZONE DEPLETION POTENTIAL (ODP),
A 4.1 YEAR ATMOSPHERIC LIFETIME, AND A 320 GLOBAL WARMING POTENTIAL
((GWP) (100 YE AR ITH, WMO 1998 METHOD). 1,
2-TRANS-DICHLOROETHYLENE HAS AN ATMOSPHERIC LIFETIME OF ABOUT 6
DAYS BASED ON ITS REACTIVITY WITH HYDROXYL RADICALS. COMPOUNDS
WITH LIFETIMES THIS SHORT HAVE OZONE DEPLET ION POTENTIALS OF ZERO
AND GLOBAL WARMING POTENTIALS OF ZERO. ETHANOL AND ISOPROPANOL HAVE
NO OZONE DEPLETION POTENTIAL AND ZERO GLOBAL WARMING POTENTIAL. THE
MIXTURE HAS A GLOBAL WARMING POTENTIAL OF 170.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE IN AN INDUSTRIAL OR COMMERCIAL
FACILITY IN THE PRESENCE OF A COMBUSTIBLE MATERIAL. COMBUSTION
PRODUCTS WILL INCLUDE HF AND HCL. SINCE REGULATIONS VARY, CONSULT
APPLICABLE REGULATIONS OR AUT HORITIES BEFORE DISPOSAL. U.S. EPA
HAZARDOUS WASTE NUMBER: NONE (NOT U.S. EPA HAZARDOUS).
=================== MSDS Transport Information ===================
Transport Information:(CONTD. FROM "TOXICOLOGICAL") EFFECTS OBSERVED.
MUTAGENICITY: NOT A MUTAGEN IN REVERSE MUTATION OR CHROMOSOMAL
ABBERATION ASSAYS. CARDIC SENSITIZATION: NO SIGNS OF SENSITIZATION
AT EXPOSURES UP TO 100 ,000 PPM. PRIMARY DERMAL IRRITATION:
MINIMALLY IRRITATING. PRIMARY OCULAR IRRITATION: PRACTICALLY
NON-IRRITATING. DERMAL SENSITIZATION: NOT A SKIN SENSITIZER.
EXPOSURE TO EXCESSIVE VAPOR CONCENTRATION IN CONFINED AREAS MAY
CAUSE SIGNIFICANT INJURY. DECOMPOSITION OF THIS PRODUCT AT
TEMPERATURES ABOVE 300C CAN FORM PERFLUOROISOBUTYLENE (PFIB), BUT
PFIB WILL ONLY (CONTD. SEE "SARA TITLE I I I")
===================== Regulatory Information =====================
SARA Title III Information:(CONTD. FROM "TRANSPORT") ACCUMULATE WITH
CONTINUOUS EXPOSURE TO EXCESSIVE HEAT IN A SEALED VESSEL. THE
FORMATION RATE FOR PFIB IS ABOUT 1000 TIMES LESS THAN THE RATE FOR
PRIMARY THERMAL DECOMPOSITIO N PRODUCTS SUCH AS HF. NO HEALTH
HAZARD IS ASSOCIATED WITH THE USE OF HFE PRODUCTS DUE TO PFIB
EXPOSURE. IF YOU HAVE QUESTIONS OR CONCERNS REGARDING THIS ISSUE,
PLEASE CONTACT KURT WERNER (651-733-849 4).
Federal Regulatory Information:THE COMPONENTS OF THIS PRODUCT ARE IN
CONPLIANCE WITH THE CHEMICAL REGISTRATION REQUIREMENTS OF TSCA,
ELINCS, MITI.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:WALLPAPER REMOVER
CAGE:9B440
CAGE:9B440
============= Composition/Information on Ingredients =============
Ingred Name:ISOPROPYL ALCOHOL; (ISOPROPANOL)
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 6%
OSHA PEL:400 PPM;500 STEL
ACGIH TLV:400 PPM;500 STEL
Ingred Name:VOLATILE ORGANIC COMPOUNDS: 350 GRAMS/LITER
RTECS #:9999999VO
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EXCESSIVE INHALATION MAY LEAD
TO DIZZINESS, HEADACHE, NAUSEA, SWALLOWED, VOMITING MAY CAUSE
ASPIRATION INTO LUNGS, WHICH MAY LEAD TO CHEMICAL PNEUMONITIS.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:DIZZINESS, HEADACHE, NAUSEA.
Medical Cond Aggravated by Exposure:SOME SKIN CONDITIONS MAY BE
AGGRAVATED.
======================= First Aid Measures =======================
First Aid:SKIN: FLUSH AREA WITH WATER FOR 15 MINUTES. EYES: FLUSH AREA
WITH WATER FOR AT LEAST 15 MINUTES. INGEST: DO NOT INDUCE VOMITING.
CALL A PHYSICIAN. INHAL: REMOVE TO FRESH AIR. SUPPORT BRTHG (GIVE
O*2/A RTF RESP) .
===================== Fire Fighting Measures =====================
Flash Point:NONE TO BOILING
Extinguishing Media:WATER, CARBON DIOXIDE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE KNOWN.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE SOURCES OF IGNITION. CONTAIN LIQUID
BY BARRICADING OR DIKING. DO NOT LET LIQUID ENTER SEWERS OR WATER
COURSES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED WHEN NOT IN USE.
STORE IN A COOL PLACE AWAY FROM HEAT AND OPEN FLAMES.
Other Precautions:NONE NECESSARY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED AIR-SUPPLIED MASK IF TLV IS
EXCEEDED.
Ventilation:LOCAL EXHAUST:PREFERRED. MECH(GEN): ACCEPTABLE.
Other Protective Equipment:SAFETY SHOWER AND EYE WASH.
Work Hygienic Practices:DO NOT SMOKE, EAT, OR DRINK AROUND MATERIAL.
WASH HANDS AFTER USE.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:208F,98C
Vapor Pres:34@20C
Vapor Density:3.2
Spec Gravity:0.92(H*2O=1)
Evaporation Rate & Reference:0.1(BUTYL ACETATE=1)
Solubility in Water:COMPLETE
Appearance and Odor:LIGHT PINK LIQUID; ALCOHOL ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:COMBUSTION MAY PRODUCE CO*2 OR CO.
==================== Disposal Considerations ====================
Waste Disposal Methods:DILUTE CONTAINED SPILL W/WATER. ABSORB SPILLS
AND DISPOSE OF I/A/W LOCAL, FEDERAL AND STATE REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:RP SUPER FILTER COAT 418
CAGE:82866
CAGE:82866
============= Composition/Information on Ingredients =============
Ingred Name:SOLUBLE HYDROCARBON OIL
Fraction by Wt: 58.35%
Other REC Limits:NONE SPECIFIED
Ingred Name:METHYLENE CHLORIDE(SARA III)
CAS:75-09-2
RTECS #:PA8050000
Fraction by Wt: 26%
Other REC Limits:NONE SPECIFIED
OSHA PEL:500 PPM/C,1000; Z2
ACGIH TLV:50 PPM, A2; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:POLYETHYLENE
RTECS #:PM9002884
Fraction by Wt: 1.20%
Other REC Limits:NONE SPECIFIED
Ingred Name:ANTI-MICROBIAL AGENT
Fraction by Wt: 0.45%
Other REC Limits:NONE SPECIFIED
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 7.00%
Other REC Limits:NONE SPECIFIED
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT; 9192
Ingred Name:ISOBUTANE
CAS:75-28-5
RTECS #:TZ4300000
Fraction by Wt: 7.00%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Effects of Overexposure:SWALLOWING MAY CAUSE VOMITING OR DIARRHEA. CAN
AFFECT CENTRAL NERVOUS SYSTEM.
Medical Cond Aggravated by Exposure:ASTHMATICS MAY EXPERIENCE BREATHING
DIFFICULTIES.
======================= First Aid Measures =======================
First Aid:GET TO FRESH AIR IF INHALED. IF CONTACT IS MADE WITH EYES,
IMMEDIATELY & THOROUGHLY FLUSH WITH WATER. IF CONTACT IS MADE WITH
SKIN, THOROUGHLY WASH WITH SOAP & WATER. IF SWALLOWED DO NOT INDUCE
VOMITI NG, CALL PHYSICIAN IMMEDIATELY.
===================== Fire Fighting Measures =====================
Lower Limits:1.9
Upper Limits:8.5
Extinguishing Media:"B" CLASS EXTINGUISHER *WATER SOLUBLE
HYDROCARBON OIL WITH CONSISTENCY OF GREASE AFTER SOLVENT
EVAPORATES.
Fire Fighting Procedures:HANDLE AS HYDROCARBON OIL. USE AIR-SUPPLIED
BREATHING EQUIPMENT FOR ENCLOSED AREAS. COOL EXPOSED CONTAINERS
WITH WATER SPRAY. AVOID BREATHING VAPORS & FUMES.
Unusual Fire/Explosion Hazard:DO NOT PUNCTURE OR INCINERATE AEROSOL
CONTAINERS. CONTENTS UNDER PRESSURE. DO NOT EXCEED 120F.
================== Accidental Release Measures ==================
Spill Release Procedures:TREAT AS WATER SOLUBLE HYDROCARBON OIL. FLUSH
WITH WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT FREEZE OR SUBJECT TO HIGH
TEMPERATURES. STORE AT 60F-90F. DO NOT HANDLE OR STORE NEAR HEAT,
SPARKS, FLAME OF STRONG OXIDANTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE AIR-SUPPLIED RESPIRATORY PROTECTION IN
CONFINED OR ENCLOSED SPACES.
Ventilation:USE LOCAL EXHAUST. USE IN WELL VENTILATED AREA. PROVIDE
GREATER THAN 60 PPM HOOD OR FACE VELOCITY FOR CONFINED SPACES.
Other Protective Equipment:USE CHEMICAL-RESISTANT APRON OR OTHER
CLOTHING IF NEEDED TO AVOID PROLONGED SKIN CONTACT.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:360F,182C
Vapor Density:1.5-2.0
Spec Gravity:0.94
Solubility in Water:*
Appearance and Odor:AMBER COLORED GREASE WITH BLAND ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:DO NOT SPRAY MIST INTO OPEN FLAME
Hazardous Decomposition Products:SOME HYDROGEN GAS MAY DEVELOP. SMOKE,
CARBON MONOXIDE AND SULFUR OXIDES IN THE CASE OF INCOMPLETE
COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:HANDLE AS LOCAL CODES DICTATE FOR SOLUBLE OIL.
DO NOT PUNCTURE OR INCINERATE AEROSOL CONTAINERS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:BUFFER SOLUTION (BIPHTHALATE) PH 4 HY2394
CAGE:0BZ18
CAGE:0BZ18
============= Composition/Information on Ingredients =============
Ingred Name:POTASSIUM ACID PHTHALATE
CAS:877-24-7
Fraction by Wt: 1-2%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 98-99%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:SKIN AND EYE:IRRITATION.
INGESTION:GASTROINTESTINAL IRRITATION. CHRONIC:NONE LISTED BY
MANUFACTURER.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE IDENTIFIED.
======================= First Aid Measures =======================
First Aid:INGEST:IF SWALLOWED & PERSON IS CONSCIOUS, IMMED GIVE LG AMTS
OF WATER. GET MED ATTN. INHAL:IF PERSON BREATHES IN LG AMTS, MOVE
EXPOSED PERSON TO FRESH AIR. SKIN:IMMED WASH W/PLENTY OF WATER FOR
@ LEA ST 15 MINS. EYES:IMMED FLUSH W/PLENTY OF WATER FOR @ LEAST 15
MINS.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE EXTINGUISHING MEDIA APPROPRIATE FOR SURROUNDING
FIRE.
Fire Fighting Procedures:NONE IDENTIFIED. USE NIOSH/MSHA APPROVED SCBA
& FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS EXPOSED TO HEAT MAY
EXPLODE.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR SUITABLE PROTECTIVE CLOTHING. TAKE UP
WITH SAND OR OTHER NON-COMBUSTIBLE ABSORBENT MATERIAL AND PLACE
INTO CONTAINER FOR LATER DISPOSAL. FLUSH SPILL AREA WITH WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED.
SUITABLE FOR ANY GENERAL CHEMICAL STORAGE AREA. CAUTION:MAY CAUSE
IRRITATION. MAY BE HARMFUL IF SWALLOWED.
Other Precautions:DURING USE AVOID CONT W/EYES, SKIN, CLTHG.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:ANSI APPRVD EMERGENCY EYE WASH & DELUGE
SHOWER .
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
pH:4
Solubility in Water:COMPLETE (100%)
Appearance and Odor:CLEAR, COLORLESS LIQUID, ODORLESS.
Percent Volatiles by Volume:99
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE IDENTIFIED.
Stability Condition to Avoid:HEAT.
Hazardous Decomposition Products:NONE IDENTIFIED.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE, AND LOCAL ENVIRONMENTAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:FORMED MOLECULAR SIEVE
Preparer's Name:J.H.CONVEY
CAGE:0NAV2
CAGE:0NAV2
CAGE:0N140
CAGE:16210
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM OXIDE
CAS:1313-59-3
Other REC Limits:NONE RECOMMENDED
Ingred Name:CALCIUM OXIDE
CAS:1305-78-8
RTECS #:EW3100000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3
ACGIH TLV:2 MG/M3; 9192
Ingred Name:POTASSIUM OXIDE
CAS:12030-89-6
RTECS #:TT3790000
Other REC Limits:NONE RECOMMENDED
Ingred Name:SILICA GEL
CAS:112945-52-5
RTECS #:VV7310000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:6 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:ALPHA-ALUMINA (ALUMINUM OXIDE) (EPA LISTS ONLY FIBROUS
FORMS) (SARA III)
CAS:1344-28-1
RTECS #:BD1200000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9192
Ingred Name:KAOLIN
CAS:1332-58-7
RTECS #:GF1670500
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9192
Ingred Name:SILICA, CRYSTALLINE - FUSED
CAS:60676-86-0
RTECS #:VV7328000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.1 MG/M3 RDUST
ACGIH TLV:0.1 MG/M3 RDUST;9192
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT) IS >31,600 MG/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:AVOID PROLONGED BREATHING OF DUST OR
CONTACT OF DUST WITH SKIN. THE DRYING ACTION OF THIS MATERIAL CAN
CAUSE IRRITATION OF MUCOUS MEMBRANES OF NOSE AND THROAT AND
IRRITATION OF SKIN. IF ITS USE REQUIR ES MANUAL HANDLING, WEAR LONG
Explanation of Carcinogenicity:QUARTZ IS LISTED BY IARC AS CLASS 2A
CARCINOGEN.
Effects of Overexposure:EYES: IRRITATION FROM DUST. SKIN: IRRITATION,
DRYING. INHALATION: DUST MAY CAUSE DRYNESS AND IRRITATION OF MUCOUS
MEMBRANES OF MOUTH AND THROAT. INGESTION: NOT CONSIDERED A
POTENTIAL SOURCE OF EXPOSUR E.
Medical Cond Aggravated by Exposure:MANUFACTURER KNOWS OF NO MEDICAL
CONDITIONS ABNORMALLY AGGRAVATED BY EXPOSURE TO THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY WASH FROM EYES WITH LARGE AMOUNTS OF WATER,
OCCASIONALLY LIFTING UPPER & LOWER LIDS. IF IRRITATION OCCURS &
PERSISTS, SEEK MEDICAL ATTENTION. SKIN: WASH WITH SOAP AND WATER.
INGESTIO N: MATERIAL WILL PASS THROUGH BODY NORMALLY. INHALATION:
REMOVE TO FRESH AIR.
===================== Fire Fighting Measures =====================
Flash Point:NON FLAMMABLE
Extinguishing Media:NONFLAMMABLE.
Fire Fighting Procedures:NONFLAMMABLE.
Unusual Fire/Explosion Hazard:NONFLAMMABLE.
================== Accidental Release Measures ==================
Spill Release Procedures:VACUUM, SWEEP UP OR FLUSH TO SEWER TREATED FOR
SUSPENDED SOLIDS REMOVAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS TIGHTLY SEALED TO
PROTECT QUALITY.
Other Precautions:WHEN TRANSFERRING BEADED MOLECULAR SIEVES WITH HIGH
BEADS WITH ENOUGH VELOCITY TO PENETRATE THE SKIN. MAKE SURE THAT
THE TRANSFER/RECIEV ING SYSTEMS ARE PROPERLY GROUNDED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF DUSTY CONDITIONS PREVAIL THE USE OF AN
APPROVED NIOSH/MSHA DUST MASK IS RECOMMENDED.
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:WEAR LONG SLEEVES.
Work Hygienic Practices:WASH AFTER HANDLING AND BEFORE EATING,
DRINKING, OR SMOKING.
Supplemental Safety and Health
WHEN POURING INTO A CONTAINER OF FLAMMABLE LIQUID, GROUND BOTH
CONTAINERS ELECTRICALLY TO PREVENT A STATIC ELECTRIC SPARK.
================== Physical/Chemical Properties ==================
HCC:B3
Spec Gravity:2.1
pH:10.4
Solubility in Water:INSOLUBLE
Appearance and Odor:WHITE, GRAY, OR TAN BEADS. ODORLESS.
Percent Volatiles by Volume:NIL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
REACTS WITH HYDROGEN FLUORIDE, STRONG ACIDS, OR ALKALI.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:LANDFILL IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. COVER TO AVOID BLOWING OF DUST.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:28F1302
CAGE:JO842
CAGE:24446
CAGE:JO842
============= Composition/Information on Ingredients =============
Ingred Name:POLYCHLORINATED BIPHENYLS (PCBS) (SARA III)
CAS:1336-36-3
RTECS #:TQ1350000
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Effects of Overexposure:ABSORBED THRU SKIN,LUNGS,INTESTINE.CAUSES
CANCER,LIVER,KIDNEY,STOMACH,EYE,HEARING DISORDER(SUP DATA)
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/WATER IMMED.SKIN:WASH W/SOAP IMMED.INHAL:REMOVE
TO FRESH AIR.GIVE ART.RESPIR. AS NEEDED.INGEST:GET MEDICAL
ATTN.GIVE LARGE QTY OF SALT WATER,INDUCE VOMITING,BUT DO NOT MAKE
UNCONSCIOUS PE RSON VOMIT.
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT & DIKES TO PREVENT
RUNOFF.ISOLATE & NOTIFY PROPER AUTHORITIES.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE MUST FOLLOW RCRA REQUIREMENTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SUPPLIED AIR W/FULL FACEPIECE,HELMET OR HOOD
Ventilation:LOCAL EXHAUST
Other Protective Equipment:FULL CLOTHING TO PREVENT SKIN CONTACT
Supplemental Safety and Health
OVEREXPOS:CAN CAUSE FORMATION OF CYSTS.CAUSES STILLBIRTHS.IRRITATES
EYES,NOSE,THROAT.
================== Physical/Chemical Properties ==================
HCC:Z3
Appearance and Odor:LIGHT STRAW COLORED LIQUID,AROMATIC ODOR
================= Stability and Reactivity Data =================
STRONG OXIDIZERS
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-GENERALLY HIGH
TEMPERATURE INCINERATION.ONLY APPROVED DISPOSAL OPERATOR PERMITTED.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:5160-081,METHYL ALCOHOL
CAGE:62901
CAGE:62901
============= Composition/Information on Ingredients =============
Ingred Name:METHYL ALCOHOL (METHANOL) (SARA III)
CAS:67-56-1
RTECS #:PC1400000
OSHA PEL:S,200PPM/250STEL
ACGIH TLV:S,200PPM/250STEL; 93
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Effects of Overexposure:EYE:IRRIT,SKIN:DERMATITIS.
VAPOR:HEADACHE,DIZZY,NAUSEA,NARCOSIS. INGESTION:BLINDNESS OR DEATH.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH WITH WATER 15 MIN,CALL A PHYSICIAN. SKIN: WASH WITH
SOAP & WATER CALL A MD. INGESTION:GIVE WATER & INDUCE VOMITING, IF
CONSCIOUS,CALL A DOCTOR. INHALATION:REMOVE FROM EXPOSURE,GIVE ARTIF
RES P IF NEEDED,CALL A PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:52F/11C
Lower Limits:6
Upper Limits:36.5
Extinguishing Media:CO*2,DRY POWDER
Fire Fighting Procedures:WATER SPRAY TO COOL EXPOSED CONTAINERS &
DILUTE SPILLS.
Unusual Fire/Explosion Hazard:VIOLENT REACTION WITH
CCRO*3(1*2+2H+5OH+H*GO),PB(CLO*4)*2,HCLO*4,P*20*3.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB ON PAPER,EVAPORATE ON AN IRON PAN IN A
HOOD OR DILUTE WITH WATER & FLUSH TO SEWER. ELIMINATE SOURCES OF
IGNITION.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL PLACE AWAY FROM
HEAT,SPARKS & OPEN FLAMES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESP DEVICE IN ACCORD WITH
EXPOSURE OF CONCERN.
Ventilation:MECHANICAL
Other Protective Equipment:LAB COAT OR OVERALLS.
Supplemental Safety and Health
CONTAINER SIZE: GAL JUG
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:149F/65C
Vapor Pres:125
Vapor Density:1.11
Spec Gravity:0.79
Evaporation Rate & Reference:0.5(ETHYL ETHER)
Solubility in Water:COMPLETE
Appearance and Odor:CLEA, COLORLESS LIQUID,CHAR. ODOR.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIALS
==================== Disposal Considerations ====================
Waste Disposal Methods:ATOMIZE INTO A INCINERATOR OR DILUTE WITH WATER
& FLUSH SMALL AMOUNTS TO SEWER. COMPLY WITH LOCAL,STATE AND FEDERAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:INCO 901
Preparer's Name:JORGE JACOBS
CAGE:58401
CAGE:58401
============= Composition/Information on Ingredients =============
Ingred Name:NICKEL (SOLUBLE)
INTENDED CHANGE (IC)
CAS:7440-02-0
RTECS #:QR5950000
Other REC Limits:1 MG/CUM
OSHA PEL:1 MG/CUM
ACGIH TLV:0.05 MG/CUM IC (A1)
Ingred Name:CHROMIUM METAL, CHROMIUM, CHROME (SUSPECTED A1 HUMAN
CARCINOGEN BY IARC, NTP & ACGIH)
CAS:7440-47-3
RTECS #:GB4200000
Fraction by Wt: 12.5%
OSHA PEL:1 MG/CUM
ACGIH TLV:0.5 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:MOLYBDENUM (SOLUBLE COMPOUND), LEAD MOLYBDATE
CAS:7439-98-7
RTECS #:QA4680000
Fraction by Wt: 6%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3; 9293
Ingred Name:TITANIUM (DRY POWDER) (TI)
CAS:7440-32-6
RTECS #:XR1700000
Fraction by Wt: 2.7%
OSHA PEL:15 MG/CUM
ACGIH TLV:10 MG/CUM
Ingred Name:IRON
CAS:7439-89-6
RTECS #:NO4565500
Fraction by Wt: 34%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHALATION: DISCOMFORT, DIZZINESS,
NAUSEA, DRYNESS OR IRRITATION OF NOSE & THROAT. SKIN: IRRITATION.
EYES: WATERING.
Explanation of Carcinogenicity:NICKEL & CHROMIUM IS A SUSPECTED A1
HUMAN CARCINOGEN.
Effects of Overexposure:INHALATION: HEADACHE, BREATHING DIFFICULTY,
FREQUENT COUGHING & CHEST PAINS. SOME TOXIC GASES MAY CAUSE
PULMONARY EDEMA, ASPHYXIATION & EXCESSIVE EXPOSURE CAN BE FATAL.
MAY RESULT IN NEUROLOGICAL DAMA GE, LUNG FIBROSIS, PNEUMONCONSIS &
OTHER LUNG DISEASES. SKIN: IRRITATION. EYES: WATERING.
Medical Cond Aggravated by Exposure:IMPAIRED PULMONARY FUNCTION, AIRWAY
DISEASES & CONDITIONS, ASTHMA, EMPHYSEMA, CHRONIC BRONCHITIS.
======================= First Aid Measures =======================
First Aid:EYES: WASH W/LARGE AMOUNTS OF WATER. SKIN: WASH W/SOAP OR
MILD DETERGENT FOR 5 MINS. INHALATION: REMOVE FROM EXPOSURE AREA, &
ADMINISTER OXYGEN IF RESPIRATION IS DIFFICULT. IF NOT BREATHING
BEGIN ARTI FICAL RESPIRATION. IF PULSE NOT DETECTED BEGIN EXTERNAL
HEART MEASSAGE. INGESTION: OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:DRY CHEMICAL. USE MEDIA APPROPRIATE FOR SURROUNDING
FIRE.
Fire Fighting Procedures:SOLID FORM ISN'T COMBUSTIBLE UNDER NORMAL
CONDITIONS.
Unusual Fire/Explosion Hazard:MOLTEN METAL ALLOYS MAY EXPLODE ON
CONTACT W/WATER, THEY MAY ALSO REACT VIOLENTLY W/WATER, RUST, METAL
OXIDES, OXIDES OF COPPER, IRON & LEAD.
================== Accidental Release Measures ==================
Spill Release Procedures:IN SOLID FORM THIS MATERIAL POSES NO SPECIAL
CLEAN-UP PROBLEMS.
======================Handling and Storage ======================
Handling and Storage Precautions:PREVENT WASTE FROM CONTAMINATING
SURROUNDING ENVIRONMENT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED RESPIRATORS.
Ventilation:LOCAL EXHAUST VENTILATION SHOULD BE USED TO CONTROL
EXPOSURE TO AIRBORNE FUMES WHENEVER POSSIBLE.
Other Protective Equipment:USE APRON FOR WELDING.
Work Hygienic Practices:REMOVE CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Solubility in Water:INSOLUBLE
Appearance and Odor:ODORLESS FILLER METAL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:METAL FUMES
==================== Disposal Considerations ====================
Waste Disposal Methods:PRIOR TO DISPOSAL CONSIDER IF MATERIAL HAS
RECOVERY VALVE. DISCARD ANY PRODUCT IN ACCEPTABLE MANNER.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SHELL TURBO(R) T OIL 32
CAGE:54527
CAGE:0T5C6
CAGE:54527
============= Composition/Information on Ingredients =============
Ingred Name:SHELL TURBO OIL 32
Fraction by Wt: 100%
Other REC Limits:NONE RECOMMENDED
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATES,HYDROTREATED
(MILD),HEAVY PARAFFINIC
CAS:64742-54-7
RTECS #:PY8035500
Fraction by Wt: 98-99%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
Ingred Name:MINOR ADDITIVE
Fraction by Wt: 1-2%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT) IS 5 MG/M3 OIL MIST
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: PRESUMED NON-IRRITATING. SKIN:
PRESUMED NON-IRRITATING. PROLONGED AND REPEATED CONTACT MAY RESULT
IN SKIN DISORDERS SUCH AS DERMATITIS, OIL ACNE OR FOLLICULITIS.
INHALATION: INHALATION OF MISTS OR VAPORS MAY CAUSE A MILD
IRRITATION OF THE MUCOUS MEMBRANES OR THE UPPER RESPIRATORY TRACT.
INGESTION: SLIGHTLY TOXIC.
Explanation of Carcinogenicity:THIS PRODUCT AND ITS COMPONENTS ARE NOT
CLASSIFIED AS CARCINOGENIC BY IARC, NTP OR OSHA.
Effects of Overexposure:NECROSIS MAY BE EVIDENCED BY DELAYED ONSET OF
PAIN AND TISSUE DAMAGE A FEW HOURS FOLLOWING HIGH PRESSURE
INJECTION.
Medical Cond Aggravated by Exposure:PREEXISTING SKIN AND RESPIRATORY
DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:EYES-FLUSH WITH WATER. IF IRRITATION OCCURS, GET MEDICAL AID.
SKIN-REMOVE CONTAMINATED CLOTHING/SHOES, WIPE EXCESS FROM SKIN.
FLUSH SKIN WITH WATER. FOLLOW BY WASHING WITH SOAP & WATER. IF
IRRITATIONOCCURS, GET MEDICAL AID. INHALATION-REMOVE TO FRESH AIR
& GIVE OXYGEN IF BREATHING IS DIFFICULT. INGEST-DO NOT INDUCE
VOMITING. IN GENERAL, NO TREATMENT IS NECESSARY UNLESS LARGE
AMOUNTS SWALLOWED.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:430F,221C
Extinguishing Media:USE WATER FOG, FOAM, DRY CHEMICAL OR CARBON
DIOXIDE. DO NOT USE A DIRECT STREAM OF WATER.
Fire Fighting Procedures:MATERIALS WILL NOT BURN UNLESS PREHEATED. DO
NOT ENTER CONFINED FIRE SPACE WITHOUT FULL BUNKER GEAR, INCLUDING A
POSITIVE PRESSURE NIOSH-APPROVED RESPIRATOR.
Unusual Fire/Explosion Hazard:PRODUCT WILL FLOAT AND CAN BE REIGNITED
ON SURFACE OF WATER.
================== Accidental Release Measures ==================
Spill Release Procedures:USE CAUTIOUS JUDGEMENT WHEN CLEANING UP LARGE
SPILLS. WEAR RESPIRATOR AND PROTECTIVE CLOTHING AS APPROPRIATE.
SHUT OFF SOURCE OF LEAK IF SAFE TO DO SO. DIKE AND CONTAIN. REMOVE
WITH VACUUM TRUCKS OR P UMP TO STORAGE/SALVAGE VESSELS. SOAK
UPRESIDUE.
Neutralizing Agent:NONE
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE WITH
ADEQUATE VENTILATION. KEEP AWAY FROM OPEN FLAMES AND HIGH
TEMPERATURES.
Other Precautions:MINIMIZE SKIN CONTACT. PROPERLY DISPOSE OF
CONTAMINATED LEATER ARTICLES, INCLUDING SHOES, THAT CANNOT BE
DECONTAMINATED. KEEP AWAY FROM OPEN FLAMES AND HIGH TEMPERATURES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF EXPOSURE MAY OR DOES EXCEED OCCUPATIONAL
EXPOSURE LIMITS, USE A NIOSH APPROVED RESPIRATOR TO PREVENT
OVEREXPOSURE. IN ACCORDANCE WITH 29 CFR 1910.134 USE EITHER AN
ATMOSPHERE-SUPPLYING RESPIRATOR F OR ORGANIC VAPOR AND PARTICLES.
Ventilation:USE LOCAL EXHAUST AND MECHANICAL VENTILATION.
Other Protective Equipment:CHEMICAL RESISTANT PROTECTIVE CLOTHING.
Work Hygienic Practices:WASH HANDS AFTER HANDLING THIS MATERIAL.
Supplemental Safety and Health
MSDS PRESENTED BY CAGE 0T5C6 FOR CONTRACT SP0451-96-MQ043.
================== Physical/Chemical Properties ==================
HCC:V6
Melt/Freeze Pt:M.P/F.P Text:-20F,-29C
Vapor Pres:<0.1
Spec Gravity:0.8735
Viscosity:30-34 CS@104F
Solubility in Water:NEGLIGIBLE
Appearance and Odor:DARK YELLOW OIL. SLIGHT HYDROCARBON ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIALS.
Stability Condition to Avoid:AVOID HEAT, OPEN FLAMES.
Hazardous Decomposition Products:CARBON MONOXIDE AND OTHER UNIDENTIFIED
ORGANIC COMPOUNDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:FOLLOW ALL APPLICABLE LOCAL, STATE AND FEDERAL
REGULATIONS WHEN DISPOSING THIS MATERIAL.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:U/C FLAT GREEN CAMOUFLAGE 34097 COMP A
Kit Part:Y
Preparer's Name:CHARLES L. GRUBBS
CAGE:98502
CAGE:98502
============= Composition/Information on Ingredients =============
Ingred Name:N-BUTYL ACETATE (SARA III)
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: <5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:150 PPM/200 STEL
ACGIH TLV:150 PPM/200STEL;9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:CYCLOHEXANONE (SARA III)
CAS:108-94-1
RTECS #:GW1050000
Fraction by Wt: <5% SKIN
Other REC Limits:NONE SPECIFIED
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:HYDRATED IRON OXIDE
CAS:20344-49-4
Fraction by Wt: <5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:10 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:METHYL ISOAMYL KETONE
CAS:110-12-3
RTECS #:MP3850000
Fraction by Wt: 10-25%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM
ACGIH TLV:50 PPM; 9293
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 50-65%
Other REC Limits:NONE SPECIFIED
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
Ingred Name:AMORPHPOUS SILICA (SILICA GEL)
CAS:112945-52-5
RTECS #:VV7310000
Fraction by Wt: <5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:10 MG/M3
ACGIH TLV:6 MG/M3
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: <5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHALE: NASAL & RESPIR IRRIT,
UNCONSCIOUS, POSS ASPHYXIATION, SLIGHT NARCOSIS. EYE: SEVERE IRRIT.
INGEST:GASTRO IRRIT, LUNG ASPIRATION CAUSES CHEM PNEUMONITIS. SKIN:
BURNS, EXTRACTS NAT OILS, DERMATIT IS. IRRIT & DEPRESSANT FOR CTRL
NERVOUSSYS, CHRONIC EXPOS CAUSE LIVER & KIDNEY DAMAGE. PROLONG
EXPOSURE LUNG DAMAGE.
Explanation of Carcinogenicity:CRYSTALLINE SILICA IS LISTED AS A
CARCINOGEN
Effects of Overexposure:INHALE:DIZZINESS, WEAKNESS, FATIGUE, NAUSEA,
HEADACHE, IRRITATION TO EYES, NOSE & THROAT. EYES:REDNESS, TEARING
BLURRED VISION & SENSATION OF SEEING HALOS AROUD LIGHTS. INGEST:
NAUSEA, VOMITING & DIAR RHEA.
Medical Cond Aggravated by Exposure:REPORTS HAVE ASSOCIATED REPEATED &
PROLONGED OCCUPATIONAL OVEREXPOSURE TO SOLVENTS WITH PERMANENT
BRAIN & NERVOUS SYSTEM DAMAGE.
======================= First Aid Measures =======================
First Aid:INHALATION: MOVE TO FRESH AIR. GIVE ARTIFICAL RESPIRATION IF
NECESSARY. SKIN: WASH WITH SOAP & WATER. EYE: FLUSH WITH WATER FOR
AT LEAST 15 MINUTES, INGESTION: DRINK ONE OR TWO GLASSES OF WATER
TO DIL UTE, DO NOT INDUCE VOMITING. GET IMMEDIATE MEDICAL ATTENTION
FOR ANY OF THE CONDITIONS LISTED ABOVE.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:40.0F,4.4C
Lower Limits:1.1
Extinguishing Media:CARBON DIOXIDE, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:WATER MAY BE INEFFECTIVE. WATER SHOULD BE USED
TO COOL CONTAINERS EXPOSED TO FIRE. FIRE FIGHTING PERSONNEL SHOULD
WEAR SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINER MAY EXPLODE, ISLATE FROM
IGNITE SOURCES. HOT SURFACE APPLICATE REQUIRES PRECAUTION.
OVEREXPOS TO DECOMP PRODUCT MAY CAUSE DELAYED HEALTH HAZARD
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. AVOID
BREATHING VAPORS, VENTILATE AREA. REMOVE WITH INERT ABSORBENT.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE CONTAINER OUT OF SUN & AWAY FROM
HEAT, SPARKS & OPEN FLAMES. CLOSE CONTAINERS AFTER USE CONSULT NFPA
CODE FOR ADDITIONAL STORAGE REQUIREMENTS.
Other Precautions:USE APPROVED BONDING & GROUNDING PROCEDURES. OBSERVE
LABEL PRECAUTIONS. KEEP TIGHTLY CLOSED & UPRIGHT TO PREVENT
LEAKS.NEVER USE PRESSURE TO EMPTY, DRUM IS NOT A PRESSURE VESSEL.
DO NOT WELD OR FLAME CUT AN EMPTY DRUM.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:ADEQUATE VENTILATION IS REQUIRED. USE NIOSH/MSHA
APPROVED RESPIRATOR DEVICE. IN CONFINED AREAS USE NIOSH/MSHA
APPROVED AIRLINE RESPIRATOR OR HOOD. SEE SAFETY EQUIPMENT SUPPLIER
FOR RECOMMENDATIONS.
Ventilation:PROVIDE SUFFICIENT VENTILATION TO CONTROL VAPOR
CONCENTRATION. FOR BAKING FINISHES, EXHAUST VAPORS EMITTED ON
HEATING.*
Other Protective Equipment:CHEMICAL RESISTANT APRON, BOOTS, OR OTHER
CLOTHING TO PREVENT SKIN CONTACT.
Work Hygienic Practices:DO NOT TAKE INTERNALLY, EYE BATH & SHOWER
SHOULD BE AVAILABLE, WASH HANDS BEFORE EATING, SMOKING OR USING
WASHROOM.
Supplemental Safety and Health
*REMOVE DECOMPOSITION PRODUCTS FORMED DURING WELDING OR FLAME CUTTING
OF SURFACES COATED WITH THIS PRODUCT. DO NOT HANDLE UNTIL THE
MANUFACTURER'S SAFETY PRECAUTIONS HAVE BEEN READ AND UNDERSTOOD.
AVO ID BREATHING SANDING DUST. INTENTIONAL MISUSE BY DELIBERATELY
CONCENTRATING & INHALING CONTENTS MAY BE HARMFUL OR FATAL.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:260F,127C
Vapor Density:> THAN AIR
Evaporation Rate & Reference:< THAN ETHER
Percent Volatiles by Volume:36
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE REASONABLY FORESEEABLE.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
SMOKE, OXIDES OF NITROGEN
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE IN AN APPROVED FACILITY, DO NOT
INCINERATE CLOSED CONTAINERS. DISPOSE OF IN ACCORDANCE WITH
FEDERAL, STATE, AND LOCAL POLLUTION CONTROL REQUIREMENTS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TPM68M ELECTROSTATIC TONER PREMIX, 17135-00
Preparer's Name:CRAIG SUNDQUIST
CAGE:IO122
CAGE:IO122
CAGE:14668
============= Composition/Information on Ingredients =============
Ingred Name:ING 11:FOR ASSIST.POSS DISP METH INCL INCIN/RECYCING FOR
USE AS PARTS CLEANING SOLV.RECYCLED MATLS SHOULD (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12:NOT BE USED WITH CALCOMP PLOTTERS.
RTECS #:9999999ZZ
Ingred Name:VENT:OF HEATING, AIR CONDITIONING, & REFRIGERATING
ENGINEERS (ASHRAE) 1980 STANDARDS IS ADEQ UNDER NORMAL CNDTNS(ING
15)
RTECS #:9999999ZZ
Ingred Name:ING 14:OF USE. UNDER SOME CNDTNS OF USE/COMBINATIONS OF
EQUIP, OFFICE VENT MAY NOT BE ADEQ. USERS SHOULD ASSURE (ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15:THAT VENT IS SUFFICIENT TO PVNT EXCEEDING EXPOS
LIMITS. USERS SHOULD CONSULT QUALIFIED VENT ENGINEER &/OR(ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16:INDUSTRIAL HYGIENIST IF CONCERN REGARDING EXPOSURE
ARISES.
Ingred Name:OTHER PROT EQUIP:REPLENISHERS MAY STAIN CLOTHING.
RTECS #:9999999ZZ
Ingred Name:ACRYLIC COPOLYMER/RESIN
CAS:28430-58-2
Fraction by Wt: <1.0%
Ingred Name:(RED) PIGMENT
Fraction by Wt: <1%
Ingred Name:HYDROCARBON PARAFFINIC SOLVENT; (ISOPARAFFINIC PETROLEUM
SOLVENT)
CAS:64742-48-9
Fraction by Wt: >98%
Other REC Limits:300 PPM (MFR)
Ingred Name:SUPP DATA:EXPOS TO LIGHT HYDROCARBON VAPS IN SAME NAPHTHA
BIOLING RANGE AS PROD CAN PRDCE ADVERSE KIDNEY EFTS IN (ING 5)
RTECS #:9999999ZZ
Ingred Name:ING 4:MALE RATS. HOWEVER, THESE EFTS WERE NOT OBSERVED IN
SIMILAR STUDIES W/FEMALE RATS & MALE & FEMALE MICE & IN(ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5:LTD STUDIES W/OTHER ANIMALS SPECIES.ADDNL, IN NUMBER
OF HUMAN STUDIES, THERE WAS NO CLINICAL EVID OF SUCH (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6:EFTS AT NORMAL OCCUP LEVELS. IT IS THEREFORE HIGHLY
UNLIKELY THAT KIDNEY EFTS OBSERVED IN MALE RATS HAVE (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7:SIGNIFICANT IMPLICATIONS FOR HUMANS EXPOSED AT OR
BELOW THE RECOMMENDED VAPOR LIMITS IN THE WORKPLACE.
RTECS #:9999999ZZ
Ingred Name:FIRST AID:GLASSES OF WATER. DO NOT INDUCE VOMITING. CALL A
PHYSICIAN IMMEDIATELY.
RTECS #:9999999ZZ
Ingred Name:SPILL PROC:PREC FOR VOL, COMBUST VAPS FROM ABSORBED MATL.
THERE IS NO REPORTABLE QTY (RQ) UNDER CERCLA REPORTING REQ.
RTECS #:9999999ZZ
Ingred Name:WASTE DISP METH:SOLV & PETROLEUM BASED OILS. CNTCT LICENSED
HAS WASTE DISP COMPANY/ENVIRONMENTAL CONTROL AGENCY (ING 12)
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50: (ORAL RAT) 5 G/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN:CAN CAUSE DRYING/IRRIT.
EYES:CNTCT MAY CAUSE IRRIT. INHAL: VAPS MAY CAUSE HDCHS & DIZZ.
INGEST:PROD HAS LOW ORDER OF ACUTE ORAL & DERMAL TOXICITY, BUT IF
ASPIRATED INTO LUNGS DURING INGEST/VOM, M AY CAUSE MILD TO SEV
PULMONARY INJURY &POSS (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:DEATH. PROD HAS BEEN EXTENSIVELY
TESTED. WHEN USED AS INTENDED, IT DOES NOT REPRESENT ANY KNOWN
HLTH/SAFETY HAZ. HIGH VAP CONC (>1000 PPM) ARE IRRIT TO EYES & RESP
TRACT, MAY CAUSE HDCHS & DI ZZ, ARE ANESTHETIC, & MAY HAVE OTHER
CNS EFTS. DEATH IS POSS IF EXPOSED TO VERY HIGH CONC FOR PRLNGD
PERIODS.(SUPP DATA)
Medical Cond Aggravated by Exposure:SKIN CONTACT MAY AGGRAVATE AN
EXISTING DERMATITIS.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH W/CLEAR WATER FOR AT LEAST 15 MIN/UNTIL IRRIT
SUBSIDES. IF IRRIT PERSISTS, CNTCT MD. SKIN:REMOVE CONTAM CLTHG.
WASH SKIN THORO W/SOAP & WATER. DO NOT REUSE CONTAM CLTHG UNTIL
SOLV HAVE BEEN REMOVED. INHAL:REMOVE VICTIMS TO FRESH AIR. CALL MD
IMMED. IF BRTHG IS IRREGULAR/STOPPED START RESUSCITATION IF
TRAINED. ADMIN OXYGEN IF AVAIL. INGEST:DILUTE CONTENTS OF STOMACH
W/SEVERAL (ING 9)
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:102F,39C
Lower Limits:0.8%
Upper Limits:7%
Extinguishing Media:FOAM, DRY CHEMICAL, CARBON DIOXIDE (CO*2), OR WATER
FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . AVOID WATER, IT TENDS TO SPREAD HYDROCARBON
FIRES.
Unusual Fire/Explosion Hazard:KEEP PROD AWAY FROM SOURCES OF IGNIT SUCH
AS HEAT, SPARKS, PILOT LIGHTS, STATIC ELEC, ELEC APPLIANCES & OPEN
FLAMES. AUTOIGNITION TEMP APPROX 293C (560F).
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL IGNIT SOURCES. RECOVER FREE PROD
BY ADDING SAND, EARTH/OTHER SUITABLE ABSORB TO SPILLED LIQ. KEEP
NON-ESSENTIAL PERS AWAY. AVOID BRTHG VAPS. VENT CONFINED SPACES.
CLEAN-UP ABSORB MATL & DISP OF PROPERLY. CONTINUE TO OBSERVE (ING
10)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS CLOSED WHEN NOT IN
USE. DO NOT SMOKE WHEN USING PRODUCT. MINIMIZE BREATHING VAPOR OR
MIST. USE WITH ADEQUATE VENTILATION.
Other Precautions:AVOID PROLONGED OR REPEATED SKIN CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NEEDED WHEN USED AS INTENDED WITH CALCOMP
PROD. IN CONCENTRATIONS EXCEEDING RECOMMENDED SAFE EXPOSURE LIMIT,
SUCH AS DURING A MAJOR SPILL, USE A NIOSH/MSHA APPROVED CHEMICAL
CARTRIDGE RESP EFFECTI VE FOR ORGANIC VAPORS.
Ventilation:NO SPEC VENT IS NEEDED WHEN USED AS INTENDED W/CALCOMP
PRODS. NORMAL OFFICE VENT CONFORMING TO AMERICAN SOCIETY(ING 12)
Other Protective Equipment:SHOULD NOT BE NEEDED WHEN USED AS INTENDED
IN CALCOMP PROD. WEAR CHEM RESISTANT APRON WHEN CLEANING MACHINES
AS (ING 16)
Work Hygienic Practices:WHENEVER HANDLING CHEMICALS, ALWAYS USE GOOD
PERSONAL HYGIEN PRACTICES, SUCH AS WASHING YOUR HANDS AFTER USING
PROD.
Supplemental Safety and Health
PH:ESSENTIALLY NEUTRAL.EVAP RATE:0.25-0.45(N-BUTYL ACETATE=1).%VOL:100%
@ 1 ATM & 25C (77F).EFTS OF OVEREXP:PERSONS SENSIT TO HYDROCARBON
EXPOS MAY EXPERIENCE DISCOMFORT WHEN EXPOSED TO CONC BELOW EST
ABLISHED SAFE LIMIT (SEE ING SECTION FOR EXPOS LIMIT INFO).LAB
ANIMAL STUDIES HAVE SHOWN THAT PRLNGD & RPTD INHAL(ING 4)
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:>320F,>160C
Vapor Pres:1@20C(68F)
Vapor Density:5
Spec Gravity:0.76 (H*2O=1)
pH:SUPDAT
Evaporation Rate & Reference:SUPP DATA
Solubility in Water:IMMISCIBLE
Appearance and Odor:RED LIQUID WITH SLIGHT PETROLEUM HYDROCARBON ODOR.
Percent Volatiles by Volume:SUPDAT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDANTS LIKE LIQUID CHLORINE, CONCENTRATED OXYGEN, AND SODIUM
HYPOCHLORITE OR CALCIUM HYPOCHLORITE.
Stability Condition to Avoid:SOURCES OF IGNITION
Hazardous Decomposition Products:SMOKE, CARBON MONOXIDE, ALDEHYDES, AND
OTHER DECOMPOSITION PRODUCTS WHICH MAY OCCUR IN THE EVENT OF
IMCOMPLETE COMBUST.
==================== Disposal Considerations ====================
Waste Disposal Methods:RCRA HAZ WASTE NO.-D001.WASTE TONERS &
REPLENISHERS ARE HAZ WASTES AS DEFINED BY 40 CFR CHAPTER 1
(FLAMM).ASSURE CONFORMITY W/ALL APPLIC FED, STATE, & LOC DISP REGS.
WASTE TONERS & REPLENISHERS ARE CO MPATIBLE FOR DISP W/MOST
NON-HALOGENATED (ING 11)
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:1813 DAISY YELLOW, INDUSTRIAL MAINTENANCE (SUPDAT)
CAGE:DO642
CAGE:DO642
CAGE:09800
============= Composition/Information on Ingredients =============
Ingred Name:PROPANE; (PROPELLANT) VP: 760.0
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 13%
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT
Ingred Name:BUTANE; (PROPELLANT) VP: 760.0
CAS:106-97-8
RTECS #:EJ4200000
Fraction by Wt: 7%
OSHA PEL:800 PPM
ACGIH TLV:800 PPM
Ingred Name:BENZENE, ETHYL-; (ETHYLBENZENE) (SARA 313)VP: 7.1
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: 1%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM; 125 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:XYLENE (SARA 313) (CERCLA)VP: 5.9
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 7%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM; 150 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:BUTYL ALCOHOL; (1-BUTANOL) (SARA 313) (CERCLA) VP: 6.6%
CAS:71-36-3
RTECS #:EO1400000
Fraction by Wt: 1%
OSHA PEL:100 PPM
ACGIH TLV:50 PPM, S, C
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ACETONE (SARA 313) (CERCLA) VP: 180.0
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 35%
OSHA PEL:1000 PPM
ACGIH TLV:750 PPM; 1000 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:2-BUTANONE; (METHYL ETHYL KETONE) (SARA 313) (CERCLA) VP:
70.0
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 9%
OSHA PEL:200 PPM
ACGIH TLV:200 PPM; 300 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:2-PENTANONE, 4-METHYL-; (METHYL ISOBUTYL KETONE) (SARA 313)
(CERCLA) VP: 16.0
CAS:108-10-1
RTECS #:SA9275000
Fraction by Wt: 5%
OSHA PEL:100 PPM
ACGIH TLV:50 PPM; 75 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ACETIC ACID, 2-METHOXY-1-METHYLETHYL ESTER;
(1-METHOXY-2-PROPANOL ACETATE) VP: 1.8
CAS:108-65-6
RTECS #:AI8925000
Fraction by Wt: 7%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 1%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:VOLATILE ORGANIC COMPOUND: 86% BY WEIGHT PER BAAQMD RULE 4B
RTECS #:9999999VO
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:EFTS OF OVEREXP: RPTD & PRLNGD OVEREXP TO SOLVS W/PERM
BRAIN & NERVOUS SYS DMG. CONTAINS A CHEM/S KNOWN TO THE (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12: STATE OF CALIFORNIA TO CAUSE CANCER, BIRTH DEFECTS
& OTHER REPRODUCTIVE HARM.
RTECS #:9999999ZZ
Ingred Name:WASTE DISP METH: DEPRESSURIZE CONTAINER. DISPOSE OF I/A/W
FEDERAL, STATE & LOCAL REGULATIONS REGARDING POLLUTION.
RTECS #:9999999ZZ
Ingred Name:HNDLG/STOR PRECS: DO NOT SMOKE - EXTING ALL FLAMES, PILOT
LIGHTS & HEATERS - TURN OFF STOVES, ELEC TOOLS & (ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15: APPLIANCES & ANY OTHER SOURCES OF IGNIT. CONSULT
NFPA CODE. USE APPRVD BONDING & GROUNDING PROCS. (ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16: CONTENTS UNDER PRESS. DO NOT PUNCTURE, INCINERATE
OR EXPOSE TO TEMPS ABOVE 110F. HEAT FROM SUNLIGHT, (ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17: RADIATORS, STOVES, HOT WATER & OTHER HEAT SOURCES
COULD CAUSE CNTNR TO BURST. DO NOT TAKE INTERNALLY. (ING 19)
RTECS #:9999999ZZ
Ingred Name:ING 18: KEEP OUT OF THE REACH OF CHILDREN.
RTECS #:9999999ZZ
Ingred Name:OTHER PRECS: PARTICULATES WHICH MAY BE PRESENT AT HAZ
LEVELS ONLY DURING SANDING/ABRADING OF DRIED FILM. IF NO (ING 21)
RTECS #:9999999ZZ
Ingred Name:ING 20:SPECIFIC DUSTS ARE LISTED, APPLIC LIMS FOR NUISANCE
DUSTS ARE ACGIH TLV 10 MG/M3 (TDUST), OSHA PEL 15 (ING 22)
RTECS #:9999999ZZ
Ingred Name:ING 21: MG/M3 (TDUST), 5 MG/M3 (RESPIRABLE FRACTION).
RTECS #:9999999ZZ
Ingred Name:RESP PROT: FROM PRODUCT, UNDERLYING PAINT OR ABRASIVE.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:IRRIT OF EYES, SKIN & RESP SYS.
MAY CAUSE NERVOUS SYS DEPRESS. EXTREME OVEREXP MAY RSLT IN UNCON &
POSS DEATH. HDCH, DIZZ, NAUS & LOSS OF COORD ARE INDICATIONS OF
EXCESS EXPOS TO VAPS/SPRAY MIST S. REDNESS & ITCH OR BURNING
SENSATION MAY INDICATE EYE/EXCESS SKIN EXPOS. CHRONIC: PRLNGD
OVEREXP TO (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:SOLV INGREDS LISTED MAY CAUSE ADVERSE
EFTS TO LIVER, URINARY, BLOOD-FORMING, CVS & REPRO SYS. METHYL
ETHYL KETONE MAY INCR NERVOUS SYS EFTS OF OTHER SOLVS. RATS EXPOS
TO TITANIUM DIOXIDE DUST @ 250 MG/M3 DEVELOPED LUNG CANCER,
HOWEVER, SUCH EXPOS LEVELS ARE NOT ATTAINABLE IN WORKPLACE. RPTS
HAVE ASSOC (ING 12)
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.
======================= First Aid Measures =======================
First Aid:INHALATION: IF AFFECTED, REMOVE FROM EXPOSURE. RESTORE
BREATHING. KEEP WARM AND QUIET. SKIN: WASH AFFECTED AREA THOROUGHLY
WITH SOAP AND WATER. REMOVE CONTAMINATED CLOTHING AND LAUNDER
BEFORE REUSE. E YES: FLUSH WITH LARGE AMOUNTS OF WATER FOR AT LEAST
15 MINUTES. GET MEDICAL ATTENTION. INGESTION: GET MEDICAL
ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:<0F,<-18C
Lower Limits:0.9%
Upper Limits:11.1%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:NIOSH APPRVD SCBA & FULL PROT EQUIP . WATER
SPRAY MAY BE INEFTIVE. IF WATER IS USED, FOG NOZZS ARE PREF. WATER
MAY BE USED TO COOL CLSD CNTNRS TO (SUPDAT)
Unusual Fire/Explosion Hazard:ISOLATE FROM HEAT, ELEC EQUIP, SPKS &
OPEN FLAME. CLSD CNTNRS MAY EXPLODE WHEN EXPOS TO EXTREME HEAT.
APPLICATN TO HOT SURFS REQS SPEC PRECS. DURING (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPKS & OPEN
FLAME. VAPS WILL ACCUM READILY & MAY IGNITE EXPLO. DURING USE &
UNTIL ALL VAPS ARE GONE: KEEP AREA VENTD - (ING 15)
Other Precautions:INTENTIONAL MISUSE BY DELIB CONC & INHAL CONTENTS CAN
BE HARMFUL/FATAL. USE ONLY W/ADEQ VENT. AVOID BRTHG VAP & SPRAY
MIST. AVOID CNTCT W/SKIN & EYES. WASH HANDS AFTER USING. THIS
COATING MAY CONTAIN MATLS CLASSIFIED AS NUISANCE (ING 20)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF PERSONAL EXPOS CANNOT BE CONTROLLED BELOW
APPLIC LIMS BY VENT, WEAR NIOSH APPRVD, PROPERLY FITTED ORG
VAP/PARTICULATE RESP. WHEN SANDING/ABRADING DRIED FILM, WEAR
DUST/MIST RESP APPRVD BY NIOSH FORDUST WHICH MAY BE GENERATED
(ING 23)
Ventilation:LOC EXHST PREF. GEN EXHST ACCEPTABLE IF EXPOS IS MAINTAINED
BELOW APPLIC EXPOS LIMS. REFER TO OSHA STDS 1910.94,107,108.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
MFR'S TRADE NAME/PART NO: & TOUCH UP SPRAY COLORS. FIRE FIGHT PROC:
PVNT PRESS BUILDUP & POSS AUTOIGNIT OR EXPLO WHEN EXPOS TO EXTREME
HEAT. EXPLO HAZ: EMER CNDTNS OVEREXP TO DECOMP PRODS MAY CAUSE HL
TH HAZ. SYMPS MAY NOT BE IMMED APPARENT. OBTAIN MED ATTN.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>0F,>-18C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Evaporation Rate & Reference:FASTER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:BY FIRE: CARBON DIOXIDE, CARBON
MONOXIDE, OXIDES OF METALS LISTED IN INGREDEIENT SECTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE FROM PROD MAY BE HAZ AS DEFINED UNDER RCRA
40 CFR 214. WASTE MUST BE TESTED FOR IGNITABILITY TO DETERM APPLIC
EPA HAZ WASTE NUMBERS. WASTE FROM PRODS CONTAINING METHYL ETHYL
KETONE MAY REQ TESTI NG FOR EXTRACTABILITY. DO NOT INCINERATE. (ING
14)
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TOLE STEEL BLUE DX-100,81448
Preparer's Name:VILMA HOLMGREN
CAGE:ITWFL
CAGE:98148
CAGE:ITWFL
CAGE:0J6X2
============= Composition/Information on Ingredients =============
Ingred Name:ETHYL ALCOHOL (ETHANOL)
CAS:64-17-5
RTECS #:KQ6300000
Fraction by Wt: 31 - 50%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM; 9596
Ingred Name:N-BUTYL ACETATE (CERCLA)
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: 31 - 50%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:150 PPM
ACGIH TLV:150 PPM/200STEL;9596
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ISOPROPYL ALCOHOL (SARA 313)
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 1 - 5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:400 PPM
ACGIH TLV:400 PPM/500STEL;9596
Ingred Name:COLLODION (WET NITROCELLULOSE)
CAS:9004-70-0
RTECS #:QW0970000
Fraction by Wt: 1 - 5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:N-BUTYL ALCOHOL (SARA 313) (CERCLA)
CAS:71-36-3
RTECS #:EO1400000
Fraction by Wt: 1 - 5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:S, C 50 PPM; 9596
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:N-PROPYL ACETATE
CAS:109-60-4
RTECS #:AJ3675000
Fraction by Wt: 1 - 5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:200 PPM
ACGIH TLV:200 PPM/250STEL;9596
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT) IS NOT KNOWN.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYE, SKIN, CNS,
RESPIRATORY & GI TRACTS. ACUTE- EYE/SKIN:MODERATE IRRITATION.
INHALE:HIGH VAPOR CONCENTRATIONS MAY PRODUCE RESPIRATORY TRACT
IRRITATION, CNS EFFECTS. ORAL:SIMILAR TO INHA LATION. CHRONIC- MAY
CAUSE SKIN SENSITIZATION OR DERMATITIS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, DROWSINESS, DIZZINESS, NAUSEA,
VOMITING, HEADACHE, WEAKNESS, ABDOMINAL DISCOMFORT, DRYNESS OF
SKIN, DERMATITIS, ABDOMINAL PAIN, TEARING, BLURRED VISION
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH PRE-EXISTING
DISEASES OF THE EYE, SKIN, RESPIRATORY TRACT, CNS MAY HAVE
INCREASED SUSCEPTIBILITY TO THE TOXICITY OF EXCESSIVE EXPOSURES.
======================= First Aid Measures =======================
First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALED:REMOVE TO FRESH
AIR. PROVIDE CPR/OXYGEN IF NEEDED. EYES:FLUSH WITH WATER FOR 15
MINUTES, HOLDING EYELIDS OPEN. SKIN:WASH WITH SOAP & WATER. ORAL:DO
NOT IN DUCE VOMITING. IF VOMITING OCCURS SPONTANEOUSLY, KEEP HEAD
BELOW HIPS TO PREVENT ASPIRATION OF LIQUID INTO THE LUNGS. GET
IMMEDIATE MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:53.0F,11.7C
Lower Limits:1.38
Upper Limits:12
Extinguishing Media:USE CARBON DIOXIDE, SAND, FOAM, DRY CHEMICAL. COOL
FIRE-EXPOSED CONTAINERS WITH WATER.
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:VAPOR IS HEAVIER THAN AIR AND CAN TRAVEL
CONSIDERABLE DISTANCE TO A SOURCE OF IGNITION AND FLASH BACK.
CONTAINERS MAY RUPTURE DUE TO VAPOR PRESSURE BUILDUP.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. ELIMINATE SOURCES
OF IGNITION. VENTILATE AREA. CONTAIN AND PICK UP SPILL WITH
NON-FLAMMABLE ABSORBENT SUCH AS SAND, EARTH, VERMICULITE OR
NON-SPARKING TOOLS. PREVENT LIQUIDFROM ENTERING SEWERS OR
WATERWAYS.
Neutralizing Agent:NOT RELEVANT
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, VENTILATED AREA AWAY
FROM SOURCES OF IGNITION AND INCOMPATIBLE MATERIALS. KEEP OUT OF
REACH OF CHILDREN. DO NOT STORE ABOVE 120F.
Other Precautions:VERY FLAMMABLE. EMPTY CONTAINERS MAY RETAIN RESIDUE.
FOLLOW ALL PRECAUTIONS. DO NOT GET IN EYES. DO NOT BREATHE VAPOR OR
MIST. AVOID PROLONGED OR REPEATED SKIN CONTACT. WASH THOROUGHLY
AFTER HANDLING. DO NOT TAKE INTERNALLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF WORKING IN CONFINED AREAS, IF EXCESSIVE
MISTING IS EXPECTED OR IF EXPOSURE MAY OR DOES EXCEED RECOMMENDED
PERMISSIBLE EXPOSURE LIMITS (PEL), WEAR NIOSH-APPROVED RESPIRATORY
PROTECTION FOR ORGANIC V APORS (REFER TO 29 CFR 1910.134).
Ventilation:MECHANICAL (GENERAL AND/OR LOCAL EXHAUST, EXPLOSION-PROOF)
VENTILATION TO MAINTAIN EXPOSURE BELOW TLV(S).
Other Protective Equipment:EYE WASH STATION, SAFETY SHOWER,
INDUSTRIAL-TYPE WORK CLOTHING, APRON
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. WASH THOROUGHLY BEFORE EATING,
DRINKING/SMOKING.
Supplemental Safety and Health
FORMULA CHANGED. SEE PNI A, SAME NSN. WARNING! SUDDEN RELEASE OF HOT
ORGANIC CHEMICAL VAPORS OR MISTS FROM PROCESS EQUIPMENT OPERATING
AT ELEVATED TEMPERATURES AND PRESSURES MAY RESULT IN IGNITION WIT
HOUT THE PRESENCE OF OBVIOUS IGNITION SOURCES.
================== Physical/Chemical Properties ==================
HCC:F2
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:163F - 257F
Vapor Density:>1
Spec Gravity:0.84
VOC Grams/Liter:6.27
Evaporation Rate & Reference:>1 (N-BUTYL ACETATE=1)
Solubility in Water:APPRECIABLE
Appearance and Odor:BLUE TRANSPARENT LOW VISCOSITY LIQUID WITH SWEET
SOLVENT ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HEAT, SPARKS, FLAMES AND OTHER SOURCES OF
IGNITION
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE MAY BE
FORMED.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL SHOULD BE IN ACCORDANCE WITH ALL LOCAL,
STATE AND FEDERAL REGULATIONS. DO NOT INCINERATE CLOSED CONTAINERS.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:5263 GLID-GUARD EPOXY CHEMICAL RESISTANT FINISH
CAGE:EO698
CAGE:01PD6
CAGE:EO698
============= Composition/Information on Ingredients =============
Ingred Name:TITANIUM DIOXIDE, TITANIUM OXIDE (SUSPECTED ANIMAL
CARCINOGEN, IARC GROUP 3)*98-2*
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 5-10%
OSHA PEL:15 MG/CUM
ACGIH TLV:10 MG/CUM (DUST)
Ingred Name:AMORPHOUS SILICA GEL, SILICON DIOXIDE *98-2*
CAS:7631-86-9
Fraction by Wt: 1-5%
Ingred Name:BENZENE (HUMAN CARCINOGEN BY IARC GROUP 1, OSHA, NTP &
ACGIH)*98-2*
CAS:71-43-2
RTECS #:CY1400000
Fraction by Wt: .01-0.1%
Other REC Limits:0.32 MG/CUM NIOSH
OSHA PEL:1 PPM
ACGIH TLV:0.5 MG/CUM (A1)
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:TRIMETHYL BENZENE
CAS:25551-13-7
RTECS #:DC3220000
Fraction by Wt: 1-5%
Other REC Limits:25 PPM
OSHA PEL:25 PPM
ACGIH TLV:123 MG/CUM
Ingred Name:1,2,4-TRIMETHYLBENZENE, PSEUDOCUMENE *98-2*
CAS:95-63-6
RTECS #:DC3325000
Fraction by Wt: 1-5%
ACGIH TLV:25 PPM
Ingred Name:1,3,5,-TRIMETHYLBENZENE
CAS:108-67-8
RTECS #:OX6825000
Fraction by Wt: 1-5%
ACGIH TLV:25 PPM
Ingred Name:XYLENE, DIMETHYLBENZENE, XYLOL (IARC - GROUP 3) *98-2*
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 1-5%
Other REC Limits:100 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM, SKIN
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:VOLATILE ORGANIC CONTENT: 10.12 WT/GAL; 481.81 G/L
RTECS #:9999999VO
Ingred Name:POLYAMIDE OF C18 FATTY ACID PRIMERS & TETA; POLYAMIDE RESIN
*98-2*
CAS:68410-23-1
Fraction by Wt: 20-30%
Ingred Name:TALC (POWDER), (ASBESTOS FREE), TALCUM; HYDROUS MAGNESIUM
SILICATE (IARC - GROUP 3) *98-2*
CAS:14807-96-6
RTECS #:WW2710000
Fraction by Wt: 20-30%
OSHA PEL:2 MG/CUM (RESP DUST)
ACGIH TLV:2 MG/CUM (RESP DUST)
Ingred Name:XYLENE, DIMETHYLBENZENE, XYLOL (IARC - GROUP 3) *98-2*
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 5-10%
Other REC Limits:100 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM, SKIN
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ETHYL BENZENE *98-2*
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: 1-5%
Other REC Limits:100 PPM
OSHA PEL:435 MG/CUM
ACGIH TLV:434 MG/CUM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SOLVENT NAPHTHA, PETROLEUM, LIGHT AROMATIC, HIGH FLASH
AROMATIC NAPHTHA, C8&10 AROMATIC HYDROCARBON *98-2*
CAS:64742-95-6
RTECS #:WF3400000
Fraction by Wt: 10-20%
Ingred Name:ETHYLENE GLYCOL PROPYL ETHER, EKTASOLVE EP,
2-PROPOXYETHANOL
CAS:2807-30-9
RTECS #:KM2800000
Fraction by Wt: 1-5%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:INHALATION: IRRITATION OF RESPIRATORY
TRACT/MUCOUS MEMBRANE/CNS DEPRESSION/ANESTHETIC
EFFECT/LUNG/LIVER/KIDNEY DAMAGE/PULMONARY
EDEMA/PNEUMOCONIOSIS/ASPHYXIATION/SENSITIZATION/DEATH. SKIN:
IRRITATION/ DERMATITIS/BURNS/ABSORPTION. EYES:
IRRITATION/CONJUNCTIVITIS/BURNS/CORNEAL INJURY. INGESTION: CNS
DEPRESSION. (SEE SUPP)
Explanation of Carcinogenicity:SEE INGREDIENTS.
Effects of
Overexposure:IRRITATION/FATIGUE/DROWSINESS/DIZZINESS/LIGHTHEADEDNES
S/HEADACHE/UNCOORDINATION/NAUSEA/VOMITING/COUGHING/SNEEZING/DIFFICU
LTY W/SPEECH/APATHY/RESPIRATORY PROBLEMS/INTOXICATION/TIGHTNESS OF
CHEST/CONFUS ION/NARCOSIS/DIFFICULTY BREATHING/LOSS OF
CONSCIOUSNESS/DEFATTING/BLISTERING/BLURRED
VISION/BLINDNESS/DIARRHEA.
Medical Cond Aggravated by Exposure:EYES, SKIN, RESPIRATORY & LUNG
DISORDERS, ASTHMA-LIKE CONDITIONS, CARDIAC ABNORMALITIES, KIDNEY,
LIVER & NERVOUS SYSTEM DISORDERS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR & RESTORE BREATHING. HAVE
TRAINED PERSON GIVE OXYGEN IF NECESSARY. SKIN: FLUSH W/WATER; THEN
WASH THOROUGHLY W/SOAP & WATER. EYES: FLUSH W/LARGE AMOUNTS OF
WATER FOR 15 MINS. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:80F
Extinguishing Media:DRY CHEMICAL/FOAM, WATER FOG, CO2.
Fire Fighting Procedures:WATER MAY BE USED TO COOL & PROTECT EXPOSED
CONTAINERS. USE FULL PROTECTIVE CLOTHING & SCBA.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT/FIRE. VAPORS MAY IGNITE EXPLOSIVELY AT
AMBIENT/FORM EXPLOSIVE MIXTURES IN AIR AT ELEVATED TEMPS.(SUPP
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE SOURCES OF IGNITION. USE
NON-SPARKING TOOLS. EVACUATE AREA. PLACE COLLECTED MATERIAL IN
PROPER CONTAINER. LARGE: SHUT OFF LEAK SAFELY. DIKE & CONTAIN. PUMP
TO STORAGE/SALVAGE VESSELS. USE AB SORBENT TO PICKUP EXCESS
RESIDUE. KEEP SALVAGEABLE
======================Handling and Storage ======================
Handling and Storage Precautions:STORE <80F. KEEP AWAY FROM HEAT,
SPARKS & OPEN FLAME. KEEP CONTAINERS TIGHTLY CLOSED & UPRIGHT WHEN
NOT IN USE. USE ONLY W/ADEQUATE VENTILATION.
Other Precautions:DON'T TAKE INTERNALLY. KEEP OUT OF REACH OF CHILDREN.
DON'T USE ON TOYS/FURNITURE/SURFACES. DON'T APPLY ON EXTERIOR
SURFACES OF DWELLING UNITS. INTENTIONAL MISUSE BY DELIBERATELY
CONCENTRATING & INHAL ING THE CONTENTS MAY BE HARMFUL/FATAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHERE RESPIRATORY PROTECTION IS REQUIRED, USE
ONLY NIOSH/MSHA APPROVED RESPIRATORS.
Ventilation:DILUTION/LOCAL EXHAUST TO PREVENT BUILD UP OF VAPORS. USE
EXPLOSION-PROOF EQUIPMENT. USE NON-SPARKING EQUIPMENT.
Other Protective Equipment:EYE WASH, SAFETY SHOWER, IMPERVIOUS
CLOTHING, APRON, BOOTS.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH HANDS THOROUGHLY AFTER HANDLING & BEFORE
EATING/SMOKING.
Supplemental Safety and Health
DISCARD CONTAMINATED LEATHER ITEMS. FIRE HAZ:VAPORS ARE >AIR, MAY
TRAVEL LONG DISTANCES TO SOURCE OF IGNITION/FLASHBACK. HLTH HZRD:
LUNG INFLAMMATION DUE TO ASPIRATION/MUCOUS MEMBRANE
IRRITATION/BURNS OF MOUTH/THROAT/STOMACH. OVEREXPOSURE TO SOLVENTS
MAY CAUSE PERMANENT BRAIN & NERVOUS SYSTEM DAMAGE.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:176-355F
Appearance and Odor:SAFETY BLUE
Percent Volatiles by Volume:55.07
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS/REDUCING
AGENTS/BASES/ALDEHYDES/KEYTONES/AMINES/ALUMINUM/ZINC/COPPER/METALS/
PEROXIDES/NITRIC ACIDS/ACIDS.
Stability Condition to Avoid:ELEVATED TEMPS, SPARKS, OPEN FLAME &
IGNITION SOURCES.
Hazardous Decomposition Products:CO/CO2/OXIDES OF NITROGEN/ACRID
FUMES/FORMALDEHYDE/AMMONIA/OXYGEN/ACIDIC GASES/LEAD
OXIDE/CHLORINE/SMOKE/SOOT/COMPOUNDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS. AVOID DISCHARGE TO NATURAL WATERS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:732 MULTI-PURPOSE SEALANT CLEAR
Preparer's Name:JACK L SHENEBERGER
CAGE:5D028
CAGE:5D028
CAGE:71984
============= Composition/Information on Ingredients =============
Ingred Name:METHYLTRIACETOXYSILANE (OBSERVE LIMITS FOR ACETIC ACID,
FORMED DURING CURING ON EXPOSURE TO WATER OR HUMID AIR)
CAS:4253-34-3
RTECS #:VV4500000
Fraction by Wt: 2%
Other REC Limits:NONE SPECIFIED
OSHA PEL:10 PPM
ACGIH TLV:10 PPM/STEL 15 PPM
Ingred Name:ETHYLTRIACETOXYSILANE (OBSERVE LIMITS FOR ACETIC ACID,
FORMED DURING CURING ON EXPOSURE TO WATER OR HUMID AIR)
CAS:17689-77-9
Fraction by Wt: 3%
Other REC Limits:NONE SPECIFIED
OSHA PEL:10 PPM
ACGIH TLV:10 PPM/STEL 15 PPM
Ingred Name:SILICA
CAS:112945-52-5
RTECS #:VV7310000
Fraction by Wt: 10%
Other REC Limits:NONE SPECIFIED
OSHA PEL:20 MPPCF
ACGIH TLV:10 MG/M3 TOTAL DUST
===================== Hazards Identification =====================
Health Hazards Acute and Chronic:EYE: IRRITATES W/REDNESS & SWELLING.
SKIN: SINGLE SHORT TERM EXPOSURE (<24 HR) IRRITATE. REPEATED
PROLONGED CONTACT (24 TO 48 HRS) MODERATELY IRRITATE. INHALATION:
NOSE, THROAT, EYE IRRITATION. ORAL: (LRG AMTS) DIGESTIVE
DISCOMFORT. NO INJURY FROM SILICA DUST DURING REASONABLE USE. IF
DUST, RESP SYSTEM INJURY POSSIBLE.
Medical Cond Aggravated by Exposure:THIS PRODUCT, AS WITH ANY CHEMICAL,
MAY ENHANCE ALLERGIC CONDITIONS ON CERTAIN PEOPLE. WE DO NOT KNOW
OF ANY MEDICAL CONDITIONS THAT MIGHT BE AGGRAVATED BY EXPOSURE TO
THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR 15 MINUTES. GET MEDICAL ATTENTION.
SKIN: WIPE OFF AND FLUSH WITH WATER. GET MEDICAL ATTENTION IF
IRRITATION DEVELOPS. INHALATION: REMOVE TO FRESH AIR. ORAL: NO
FIRST AID SHO ULD BE NEEDED.
===================== Fire Fighting Measures =====================
Flash Point Method:OC
Flash Point:250F,121C
Extinguishing Media:WATER FOG, CO2, DRY CHEMICAL, FOAM
Fire Fighting Procedures:SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING SHOULD BE WORN IN FIGHTING FIRES INVOLVING
CHEMICALS.
Unusual Fire/Explosion Hazard:NONE KNOWN TO DOW CORNING.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE PRODUCT AND CONTAIN FOR SALVAGE OR
DISPOSAL. USE PROPER PROTECTION, SAFETY GLASSES AS A MINIMUM. USE
RESPIRATORY PROTECTION UNLESS LOCAL EXHAUST VENTILATION IS ADEQUATE
OR AIR SAMPLING DATA SHO W BELOW TLV/PEL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE <90F.KEEP CNTNR CLSD.TRACES OF
FORMALDEHYDE/OTHER DECOMP PROD FORM AT TEMP >150C. REQ MORE
PRECAUTIONS FOR USE AT ELEVATED TEMPS/AEROSOLS APPLIC
Other Precautions:GOOD PRACTICE REQUIRES THAT GROSS AMOUNTS OF ANY
CHEMICAL BE REMOVED FROM SKIN AS SOON AS PRACTICAL, ESPECIALLY
BEFORE EATING OR SMOKING. AVOID BREATHING VAPORS & EYE & SKIN
CONTACT. USE ONLY WITH ADE QUATE VENTILATION. DONT INGEST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:ACID GAS/ORGANIC VAPOR TYPE
Ventilation:LOCAL EXHAUST MAY BE NEEDED. MECHANICAL (GENERAL)
RECOMMENDED.
Other Protective Equipment:WASHING AT MEALTIME & END OF SHIFT IS
ADEQUATE. REMOVE CONTAMINATED CLOTHING & SHOES ASAP, THOROUGHLY
CLEAN BEFORE REUSE
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:V5
Vapor Pres:<5 MM
Vapor Density:>1
Spec Gravity:1.04
Solubility in Water:LESS THAN 0.1
Appearance and Odor:ACETIC ACID-LIKE, PASTE, CLEAR
Percent Volatiles by Volume:<5
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIAL CAN CAUSE A REACTION. AIR OR MOISTURE CAUSES CURING
AND ACETIC ACID VAPORS FORM.
Stability Condition to Avoid:EXPOSURE TO AIR OR MOISTURE UNTIL READY TO
USE.
Hazardous Decomposition Products:SILICON DIOXIDE, CARBON DIOXIDE,
TRACES OF INCOMPLETELY BURNED CARBON PRODUCTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DOW CORNING SUGGESTS THAT ALL LOCAL, STATE AND
FEDERAL REGULATIONS CONCERNING HEALTH AND POLLUTION BE REVIEWED TO
DETERMINE APPROVED DISPOSAL PROCEDURES. CONTACT DOW CORNING IF
THERE ARE ANY DISPOSAL QUESTIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TT-S-711C
CAGE:33151
CAGE:33150
CAGE:33151
============= Composition/Information on Ingredients =============
Ingred Name:PIGMENTS
Fraction by Wt: 6.6% *
Other REC Limits:* % WT. STAIN
Ingred Name:VEHICLE
Fraction by Wt: 93.4% *
Other REC Limits:* % WT. STAIN
Ingred Name:SOLVENTS
Fraction by Wt: 62.4% *
Other REC Limits:* % WT. STAIN
ACGIH TLV:100 PPM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Health Hazards Acute and Chronic:VAPORS MIGHT BE IRRITATING TO EYES,
NOSE AND THROAT. REPEATED EXCESSIVE EXPOSURE MAY RESULT IN
HEADACHE, DIZZINESS, SLEEPINESS AND NAUSEA. DEFATTING TO SKIN.
Effects of Overexposure:VAPORS MIGHT BE IRRITATING TO EYES, NOSE AND
THROAT. REPEATED EXCESSIVE EXPOSURE MAY RESULT IN HEADACHE,
DIZZINESS, SLEEPINESS AND NAUSEA. DEFATTING TO SKIN.
======================= First Aid Measures =======================
First Aid:INHALATION: PROVIDE FRESH AIR AND REST. SKIN CONTACT: WASH
WITH MILD SOAP AND WATER. USE EMOLLIENT CREAM OR LOTION. EYE
CONTACT: WASH WITH A GENTLE STREAM OF WATER FOR 10 MINUTES. SEE A
DOCTOR.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:105 F/41 C
Lower Limits:1.0
Upper Limits:6.0
Extinguishing Media:FOAM, CO2, DRY CHEMICALS.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD WEAR SELF CONTAINED
RESPIRATORS. WATER STREAM WILL SPREAD OIL FIRES.
Unusual Fire/Explosion Hazard:KEEP WORK AREAS FREE FROM HOT METAL
SURFACES AND OTHER SOURCES OF IGNITION. VAPOR FORMS EXPLOSIVE
MIXTURE BETWEEN UPPER AND LOWER EXPLOSIVE UNITS.
================== Accidental Release Measures ==================
Spill Release Procedures:AVOID FLAME AND SPARK SOURCES. PROVIDE
ADEQUATE VENTILATION. WIPE UP SPILL WITH INERT ABSOBENT(S) AND
NON-SPARKING TOOLS. SAFELY DISCARD SATURATED ABSORBENTS(S). AVOID
PROLONGED BREATHING OF VAPORS WH ILE CLEANING UP SPILL.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID OPEN FLAME AND SPARK SOURCES.
PROVIDE ADEQUATE VENTILATION. AVOID EXCESSIVE HEAT.
Other Precautions:DO NOT TAKE INTERNALLY. AVOID PROLONGED OR REPEATED
CONTACT WITH SKIN. AVOID PROLONGED OR REPEATED BREATHING OF VAPORS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:ORGANIC CANNISTER MASK OR AIR PACK IF
VENTILATION IS IN ADEQUATE.
Ventilation:MECHANICAL: WITH APPROVED CLASS D EXPLOSION PROOF MOTOR AND
SWITCHES.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:315F,157C
Vapor Pres:1 @ 100 F
Vapor Density:5.0
Spec Gravity:.901 (H2O=1)
Evaporation Rate & Reference:.13 (N-BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:MAHOGANY COLORED LIQUID. HYDROCARBON ODOR.
Percent Volatiles by Volume:72
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products:CO, CO2, ACRID FUMES AND SMOKE WHEN
COMBUSTED.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL PROCEDURES MUST COMPLY WITH LOCAL,
STATE AND FEDERAL REGULATION.
09JAN91
| 1 | gloves_mandatory |
=======================================================
Product ID: CHEMFAST 235, HAZE MED GRAY 235B2534
Cage: JO517
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 01PD6
Cage: JO517
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: YES
IARC: YES
OSHA: NO
Effects of Exposure: INHAL:RESP TRACT & MUC MEMB IRRIT, FATG, DROW, DIZZ
&/OR LT HEAD, HDCH, UNCOORD, NAUS, VOMIT, DIARR, ABDOM PAIN, CHEST PAIN,
COUGH, NUMB, SPEECH DFCLTY, APATHY, CNS DEPRESS, RESP PROBS, INTOXICATION,
METALLIC TASTE, ANESTH EFT/NARCOS, DFCLTY BRTHG, FEVER & CHILLS,
DEHYDRATION, LIVER & KIDNEY DMG, (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: SEE "LR" VERSION, INGREDIENT 23, FOR ADDITIONAL
INFO (FP N).
Signs And Symptions Of Overexposure: HLTH HAZ: PULM EDEMA, PNEUMOCONIOSIS,
UNCON, RESP FAILURE, ASPHY, DEATH. RESP TRACT SENSIT. SKIN:DERM, DEFAT,
BLISTERS, ALLERGIC RESPONSE, SEV IRRIT/BURNS. EYE:CONJ, BLURRED VISION,
TEARING, REDNESS, SEV IRRIT, CORNEAL INJURY. INGEST:LUNG INFLAM & DMG
DUE TO ASPIR INTO LUNGS; MOUTH, THROAT & MUC MEMB IRRIT,
Medical Cond Aggravated By Exposure: EYE, SKIN, RESPIRATORY DISORDERS, LUNG
DISORDERS, ASTHMA-LIKE CONDITIONS, KIDNEY DISORDERS, LIVER DISORDERS.
First Aid: INHAL:REMOVE TO FRESH AIR. RESTORE & SUPPORT BRTHG. HAVE TRAINED
PERSON GIVE OXYG IF NEC. GET EMER MED ATTN. SKIN:FLUSH W/WATER THEN WASH
THOROUGHLY W/SOAP & WATER. REMOVE CONTAMD CLTHG; WASH BEFORE R EUSE. IF
IRRIT OCCURS, CONSULT MD. EYE:FLUSH IMMED W/LG AMTS OF WATER ESP UNDER LIDS
FOR @ LST 15 MIN. IF EFTS PERSIST OBTAIN MED ATTN. INGEST:OBTAIN MED ATTN
IMMED. CNTCT NEHC FOR MORE INFO (FP N).
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: ELIM IGNIT SOURCES. LG SPILL:SHUT OFF LEAK IF SAFE TO
DO SO. DIKE & CNTN SPILL. PUMP TO STOR/SALVAGE VESSELS. USE ABSORB TO
PICK UP RESIDUE. KEEP OUT OF SEWERS & WATER COURSES. SM SPILL:USE ABSORB
TO PICK UP & DISP. CNTCT NEHC FOR MORE INFO (FP N).
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE IN ACCORDANCE WITH ALL APPLICABLE FEDERAL,
STATE AND LOCAL REGULATIONS. AVOID DISCHARGE TO NATURAL WATERS. CONTAINS A
CHEMICAL THAT IS TOXIC TO FISH.
Handling And Storage Precautions: STORE <100F(38C), KEEP AWAY FROM HEAT,
SPKS & OPEN FLAME. KEEP AWAY FROM DIRECT SUN, HEAT & IGNIT SOURCES.
KEEP CNTNR TIGHTLY CLSD IN WELL VENTD AREA.
Other Precautions: DO NOT TAKE INTERNALLY. KEEP OUT OF REACH OF CHILDREN. KEEP
CNTNRS TIGHTLY CLSD & UPRIGHT WHEN NOT IN USE. AVOID CNDTNS RSLTG IN FORM
OF INHAL PARTICLES/USE RESP PROT. CONTACT NECH FOR MORE INFORMATIO N (FP N).
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: 100F,38C
Extinguishing Media: DRY CHEMICAL OR FOAM WATER FOG. CARBON DIOXIDE.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA AND FULL PROTECTIVE EQUIPMENT
(FP N). WATER MAY BE USED TO COOL AND PROTECT EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard: CLSD CNTNRS MAY EXPLODE WHEN EXPOS TO EXTREME
HEAT/FIRE. VAPS ARE HVR/AIR & MAY TRAVEL LONG DISTS TO SOURCE OF IGNIT
& FLASH BACK. VAPS CAN FORM EXPLO (SUPDAT)
=======================================================
Control Measures
=======================================================
Respiratory Protection: WHERE RESPIRATORY PROTECTION IS REQUIRED, USE ONLY
NIOSH APPROVED RESPIRATORS IN ACCORDANCE WITH OSHA STANDARD 29 CFR 1910.134.
Ventilation: PROVIDE DILUTION VENTILATION OR LOCAL EXHAUST TO PREVENT BUILD-UP
OF VAPORS. USE EXPLOSION-PROOF EQUIPMENT.
Other Protective Equipment: ANSI APPROVED EYE WASH & DELUGE SHOWER (FP N).
IMPERVIOUS CLOTHING, FACESHIELD, APRON.
Work Hygienic Practices: USE ONLY W/ADEQ VENT. AVOID CNTCT W/SKIN & EYES &
BRTHG VAPS. WASH HANDS THOROUGHLY AFTER HNDLG ESP BEFORE EATING/SMKNG.
Supplemental Safety and Health: USERS OF "L" VERSION SHOULD CONSULT "LR"
VERSION FOR ADDNL INFO(FP N). EXPLO HAZ:MIXS IN AIR AT ELEVATED TEMPS. CLSD
CNTNRS MAY BURST IF EXPOS TO EXTREME HEAT/FIRE. MAY DECOMPOSE UNDER FIRE
CNDTNS EMI TTING IRRIT &/OR TOX GASES. MAY BE FLAMIN FINELY DIVIDED &
SUSPENDED STATE. MATL TO AVOID: & MINERAL ACIDS. NITRATES.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: >243F,>117C
Spec Gravity: 1.417 (FP N)
VOC Grams/Liter: 291
Appearance and Odor: NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume: 34.42
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: ELEVATED TEMPERATURES, CONTACT WITH OXIDIZING
AGENT, STORAGE NEAR ACIDS, SPARKS, OPEN FLAME. IGNITION SOURCES.
Materials To Avoid: OXIDIZERS, ACIDS,BASES, ALDEHYDES, ALKYL HALIDES, AMINES.
ALKALIS ALUMINUM,ALKALI METAL, EPOXIDES; NITRIC,LEWIS (SUPDAT)
Hazardous Decomposition Products: CO, CO*2, OXIDES OF NITROGEN, ACRID FUMES,
OXIDES OF SULFUR, ALDEHYDES, TOX GASES. CNTCT NEHC FOR MORE INFO (FP N).
Hazardous Polymerization Indicator: YES
Conditions To Avoid Polymerization: MAY POLYMERIZE IN PRESENCE OF ALIPHATIC
AMINES.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
Other Information: VOLATILE ORGANIC COMPOUND: 291.14 G/L
=======================================================
HAZCOM Label
=======================================================
Product ID: CHEMFAST 235, HAZE MED GRAY 235B2534
Cage: JO517
Assigned IND: Y
Company Name: ICI PAINTS DIV GLIDDEN
Street: 925 EUCLID AVE
Zipcode: 44115
Label Required IND: Y
Date Of Label Review: 08/12/1998
Status Code: C
Label Date: 08/12/1998
Origination
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Severe
Fire Hazard: Moderate
Reactivity Hazard: Slight
Hazard And Precautions: HAZARDOUS POLYMERIZATION MAY OCCUR. COMBUSTIBLE. INHAL:
IRRIT, FATG, NAUS, VOMIT, DIARR, ABDOM PAIN, CHEST PAIN, COUGH, NUMB, CNS
DEPRESS, INTOXICATION, METALLIC TASTE, FEVER, CHILLS, DEHYDRATION, LIV ER
& KIDNEY DMG, PULM EDEMA, PNEUMOCONIOSIS, UNCON, RESP FAILURE, ASPHY,
DEATH. RESP TRACT SENSIT. SKIN: DERM, DEFAT, BLISTERS, ALLERGIC RESPONSE, SEV
IRRIT/BURNS. EYE: CONJ, BLURRED VISION, TEARING, REDNESS, SEV IRRIT, CORNEAL
INJURY. INGEST: LUNG INFLAM. ASPIR HAZ-LUNG DMG, ABDOM PAIN, CNS DEPRESS
& EFTS, BURNS. CHRONIC: CANCER HAZARD. CONTAINS MATLS WHICH ARE LISTED AS
LUNG CARCINOGENS (FP N). SKIN & RESPIRATORY SENSITIZATION.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:METCO 82VF-NS, DIAMALLOY 3005
Resp. Party Other MSDS Num.:50-510
CAGE:01FK3
CAGE:01FK3
============= Composition/Information on Ingredients =============
Ingred Name:CHROMIUM
CAS:7440-47-3
RTECS #:GB4200000
= Wt:82.
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:NICKEL
CAS:7440-02-0
RTECS #:QR5950000
= Wt:5.5
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:CARBON
CAS:7440-44-0
RTECS #:FF5250000
= Wt:12.5
OSHA PEL:10 MG/M3
ACGIH TLV:2 MG/M3
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES
Health Hazards Acute and Chronic:EYE CONTACT: POSSIBLE CONJUNCTIVAL
IRRITATION, LACRIMATION. SKIN CONTACT: POSSIBLE DERMITITIS,
SENSITIZATION OR CHROME LESIONS, DISCOLORATION. INHALTION: POSSIBLE
IRRITATION TO THE RESPIRATORY SYSTEM, MUCOUS MEMBRANE IRRITAITON
OR ULCERATION. INGESTION: POSSIBLE IRRITATION TO GASTROINTESTINAL
TRACT AND RESPIRATORY SYSTEM, LOSS OF MUSCULAR COORDINATION,
CONFUSION AND CONVULSIONS.
Explanation of Carcinogenicity:ACGIH CLASSIFIED A1 CONFIRMED HUMAN
CARCINOGEN. IARC CLASSIFICATION GROUP 1 CACINOGENIC TO HUMANS. NTP
CLASSIFIES NICKEL AS REASONABLY ANTICIPATED TO BE CARCINOGENS.
HEXAVALENT CHROMIUM FORMED DURING THE THERMAL SPRAY PROCESS IS A
CARCINOGEN THAT MAY CAUSE BRONCHOGENIC, LUNG AND STOMACH CANCER.
SEE CHROMIUM IN "OTHER INFO" FIELD FOR ADDITIONAL INFORMATION.
Effects of Overexposure:EYE CONTACT: CONJUNCTIVAL IRRITATION,
LACRIMATION. SKIN CONTACT: DERMITITIS, SENSITIZATION, CHROME
LESIONS, DISCOLORATION. INHALTION:IRRITATION OF RESPIRATORY
SYSTEM, MUCOUS MEMBRANE IRRITAITON, ULCERATION. INGESTION:
IRRITATION OF GASTROINESTINAL TRACT AND RESPIRATORY SYSTEM, LOSS OF
MUSCULAR COORDINATION, CONFUSION, CONVULSIONS.
Medical Cond Aggravated by Exposure:CONSULT A PHYSICIAN.
======================= First Aid Measures =======================
First Aid:EYE CONTACT: FLUSH WITH WATER FOR 15-20 MINUTES, WHILE
HOLDING EYELIDS OPEN. IF IRRITATION PERSISTS, CONSULT PHYSICIAN.
SKIN CONTACT: WASH WITH SOAP AND WATER. IF IRRITATION PERSISTS,
CONSULT PHYSICIA N. INHALTION: MOVE TO FRESH AIR. CONSULT PHYSICIAN
IF IRRITATION OR RESPIRATORY DISTRESS PERSISTS. INGESTION: CONSULT
PHYSICIAN.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE CLASS D FIRE EXTINGUISHER OR SAND.
Fire Fighting Procedures:TREAT AS METALLIC FIRE. USE NIOSH / MSHA
APPPROVED SELF-CONTAINED BREATHING APPARATUS AND FULL PROTECTIVE
CLOTHING IF INVOLVED IN FIRE. (CONTD. FROM "EXPLOSION HAZARD") MAY
BE EXPLOSIVE WHEN EXPOSED T O HEAT, FLAME OR OXIDES, PEROXIDES,
OXOSALTS, HALOGENS, INTERHALOGENS, OXYGEN, BROMATES, CHLORATES, AND
IODATES.
Unusual Fire/Explosion Hazard:FINE METAL DUSTS ARE FLAMMABLE AND MAY
EXPLODE WHEN EXPOSED TO HEAT/FLAME/OXIDIZERS. CHROMIUM MAY IGNITE
IF AIRBORNE IN THE PRESENCE OF AN IGNITION SOURCE. CARBON REACTS
VIOLENTLY WITH CHLORINE TRIFLU ORIDE, POTASSIUM, FLUORINE AND
POTASSIUM SUPEROXIDE. DUSTS OF CARBON (CONTD. SEE "FIRE FIGHTING
PROCEDURE")
================== Accidental Release Measures ==================
Spill Release Procedures:EMPTY PRODUCT CONTAINERS, PRODUCT WASTE, AND
CLEANING MEDIA SHOULD BE STORED AND DISPOSED OF ACCORDING TO THE
APPROPRIATE LOCAL, STATE AND FEDERAL REGULATORY GUIDELINES.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE / HANDLING: STORE AWAY FROM
INCOMPATIBLES. STORE PRODUCT CONTAINERS IN A WELL-VENTILATED CLEAN,
COOL, AND DRY AREA. STORE IN A MANNER TO MINIMIZE PUNCTURES AND
BREAKAGE OF CONTAINERS.
Other Precautions:AVOID INGESTION, INHLATION, AND EXCESSIVE SKIN
CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:A RESPIRATOR APPROVED BY NIOSH WITH FILTER
CARTRIDGES APPROVED FOR DUST/FLAMES/MISTS SHOULD BE WORN AT ALL
TIMES DURING THE THERMAL SPRAY PROCESS TO PROTECT THE OPERATOR FROM
EXPOSURE TO DUST AND FLAM ES. RESPIRATORS MAY ALSO BE WORN WHEN
PRODUCT HANDLING GENERATES DUST.
Ventilation:PRODUCT SHOULD BE USED WITH THE APPROPRIATE LOCAL EXHAUST
VENTILATION .
PROCESS.
Other Protective Equipment:EAR PROTECTION MUST BE WORN WHEN THE
OPERATOR IS SUBJECTED TO EXCESSIVE NOISE LEVELS. WEAR AN ALUMINIZED
APRON DURING PLASMA SPRAY PROCESS. OTHER APPROPRIATE PROTECTIVE
CLOTHING MAY(CONTD. SEE "SUPPL")
Work Hygienic Practices:EYE WASH STATIONS AND WASH FACILITIES ARE
NECESSARY DURING OTHER THAN PLASMA SPRAY PHASE OF PRODUCT HANDLING
TO AVOID EXCESS SKIN CONTACT.
Supplemental Safety and Health
(CONTD. FROM "OTHER PROTECT EQUIP.") BE WORN AS NECESSARY DURING
PRODUCT HANDLING TO AVOID EXCESSIVE CONTACT WITH THE SKIN.
================== Physical/Chemical Properties ==================
HCC:T7
Melt/Freeze Pt:=1204.4C, ######F
M.P/F.P Text:2200F-2700F
Spec Gravity:2.8 (H20=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:POWDER; NO ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CHROMIUM IS INCOMPATIBLE WITH STRONG OXIDIZERS, NICKEL IS INCOMPATIBLE
WITH ACIDS, SULFUR, SELENIUM, WOOD OTHER COMBUSTIBLES AND NICKEL
NITRATE. CARBON IS INCOMPATIBLE WITH AIR, METALS, OXIDANTS, AND
UNSATURATED OILS.
Hazardous Decomposition Products:OZONE AND NITRIC ACID ARE FORMED BY
PLASMA FLAME (SIMILAR TO WELDING FLAMES).THIS ACTION IS INDEPENDENT
OF METAL POWDER.HAZARDOUS DECOMPOSITION PRODUCTS OF CARBON ARE
CARBON MONOXIDE AND CARBON DIOXIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
=================== Toxicological Information===================
Toxicological Information:NICKEL: HAZARD BY INHALATION, INGESTION, SKIN
AND EYE CONTACT. INHALATION MAY CAUSE IRRITATION 0F RESPIRATORY
SYSTEM, CENTRAL NERVOUS SYSTEM DEPRESSION, CANCERS OF LUNG AND
NASAL SINUSES. INGESTION MA Y CAUSE IRRITATION OF GASTROINTESTINAL
TRACT, LOSS OF MUSCULAR COORDINATION, CONFUSION,, CONVULSIONS. SKIN
CONTACT MAY CAUSE DERMATITIS. EYE CONTACT MAY CAUSE IRRITATION.
ACGIH CLASSIFIED A1 CONFIRMED HUMAN CARCINOGEN. IARC
CLASSIFICATION GROUP 1 CARCINOGENIC TO HUMANS. NTP CLASSIFIES
NICKEL AS REASONABLY ANTICIPATED TO BE CARCINOGENS. TARGET ORGANS:
RESPIRATORY SYSTEMCENTRAL NERVOUS SYSTEM, GAS TROINTESTINAL TR
ACT, SKIN, EYES.
===================== Ecological Information =====================
Ecological:TOXICOLOGICAL CONTD: CARBON: HAZARD BY INHALATION,
INGESTION, SKIN, AND EYE CONTACT. INHALATION MAY CAUSE IRRITATION
TO THE RESPIRATORY SYSTEM. INGESTION MAY CAUSE IRRITATION TO THE
RESPIRATORY SYSTEMAND GASTROINTESTINAL TRACT. SKIN AND EYE
CONTACT MAY CAUSE IRRITATION. TARGET ORGANS: RESPIRATORY SYSTEM,
GASTROINTESTNAL TRACT, SKIN, EYES.
==================== Disposal Considerations ====================
Waste Disposal Methods:EMPTY PRODUCT CONTAINERS, PRODUCT WASTE AND
CLEANING MEDIA SHOULD BE STORED AND DISPOSED OF ACCORDING TO THE
APPROPRIATE LOCAL, STATE AND FEDERAL REGULATORY GUIDELINES.
=================== MSDS Transport Information ===================
Transport Information:UNIT OF ISSUE IS 5 POUND CONTAINER. RQ FOR
NICKEL: 100 POUNDS; RQ FOR CHROMIUM: 5000 POUNDS. PARTICLE SIZE
<0.004 INCHES DIAMETER.
===================== Regulatory Information =====================
SARA Title III Information:CHROMIUM (7440-47-3), 82 % WT AND NICKEL
(7440-02-0), 5.5 % WT, ARE SUBJECT TO THE REPORTING REQUIREMENTS OF
SECTION 313 AND SUPPLIER NOTIFICATION REQUIREMENTS (40 CFR PART
372).
Federal Regulatory Information:CHROMIUM (7440-47-3), 82 % WT AND NICKEL
(7440-02-0), 5.5 % WT. ARE ON THE LIST OF HAZARDOUS AIR POLLUTANTS
THAT ARE REGULATED UNDER SECTION 112 OF THE EPA CLEAN AIR ACT,
1990.
State Regulatory Information:(CONTD. FROM "OTHER INFO") IARC
CLASSIFICATION GROUP 1 CARCINOGENIC TO HUMANS. NTP CLASSIFIES
HEXAVALENT CHROMIUM AS KNOWN TO BE CARCINOGENIC. SKIN CONTACT MAY
CAUSE DISCOLORATION. EYE CONTACT MAY CA USE CONJUNCTIVAL
IRRITATION, LACRIMATION. TARGET ORGANS: RESPIRATORY SYSTEM,
GASTROINTESTINAL TRACT, SKIN, EYES.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:EA 940 NA 5 MIL, AT9174
Preparer's Name:SUZANNE FRANZ
CAGE:33564
CAGE:33564
============= Composition/Information on Ingredients =============
Ingred Name:SILICA GEL; (SILICA, AMORPHOUS)
CAS:112945-52-5
RTECS #:VV7310000
Fraction by Wt: <20%
Ingred Name:M-PHENYLENEDIAMINE
CAS:108-45-2
RTECS #:SS7700000
Fraction by Wt: <3%
OSHA PEL:0.1 MG/M3, S
ACGIH TLV:0.1 MG/M3, S
Ingred Name:ANILINE, 4,4'-METHYLENEDI-; (4,4'-METHYLENE DIANILINE)
CAS:101-77-9
RTECS #:BY5425000
Fraction by Wt: <3%
ACGIH TLV:0.1 PPM, S
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:ANISOLE,2,4-DIAMINO-; (2,4 DIAMINOANISOLE)
CAS:615-05-4
RTECS #:BZ8580500
Fraction by Wt: <3%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:(ACUTE & CHRONIC) ACUTE HAZARDS OF THE
MIXTURE MAY INCLUDE POISONING. BREATHING OF VAPORS FROM CURING
MATERIAL MAY CAUSE DELAYED OR SERIOUS INJURY TO THE LIVER AND
SPLEEN (TOXIC HEPATITIS).
Explanation of Carcinogenicity:METHYLENE DIANILINE: GROUP 2B (IARC);
GROUP 2 (NTP).
Effects of Overexposure:IRRITATION OF SKIN.
Medical Cond Aggravated by Exposure:NOT APPLICABLE.
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH WITH WATER FOR AT LEAST 15 MINUTES.
SKIN: FLUSH WITH WATER. WASH AREA OF CONTACT WITH SOAP AND WATER,
RUBBING ALCOHOL OR HAND CLEANER. DO NOT USE SOLVENTS. REMOVE
CONTAMINATED CLOTHING AND LEATHER GOODS AND DISPOSE OF AS HAZ
WASTE. IF IRRIT PERSISTS, SEE MD. INGEST: CALL MD IMMEDIATELY .
INHAL: REMOVE TO FRESH AIR. SUPPORT BRTHG (GIVE O*2/ARTF RESP) .
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:>300F,>149C
Extinguishing Media:DRY CHEMICAL OR HALON FIRE EXTINGUISHER, OR WATER
SPRAY, FOAM OR FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:DENSE SMOKE AND TOXIC GASES MAY BE
LIBERATED.
================== Accidental Release Measures ==================
SCRAPE UP AND TRANSFER TO METAL CNTNR. WIPE UP REMAINING RESIDUE
WITH SOLVENTS, OBSERVING SOLVENT FLAMMABILITY CAUTIONS. MATERIALS
USED FOR CLEAN-UP ARE ALSOCONTAMINATED BY CHEMICALS. DISPOSE OF
PROPERLY.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP COOL IN ACCORDANCE WITH LABEL
INSTRUCTIONS. STORE AT -40F FOR 3 MONTHS.
Other Precautions:FOLLOW RECOMMENDED CURING SCHEDULE. KEEP MATL OFF
BODY. WASH IMMEDIATELY UPON EXPOSURE. DISPOSE OF CONTAM MATLS AS
HAZ WASTE. SEE NIOSH BULLETIN ON MDA.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NEEDED WITH GOOD INDUSTRIAL VENTILATION
UNLESS MIXING WITH ALCOHOLS AND HEATING, THEN WE RECOMMEND
NIOSH/MSHA APPROVED SCBA.
Ventilation:LOCAL EXHAUST RECOMMENDED.
Other Protective Equipment:AS NEEDED TO PROTECT SKIN AND CLOTHING; WE
RECOMMEND SPECIAL TYVEK COVERALLS.
Work Hygienic Practices:WASH IMMEDIATELY UPON EXPOSURE.
Supplemental Safety and Health
CNDTNS (POLYM): BUILD-UP AND RELEASE OF TOXIC GASES MAY OCCUR.
================== Physical/Chemical Properties ==================
HCC:T6
Boiling Pt:B.P. Text:DECOMPOSES
Solubility in Water:NIL
Appearance and Odor:BROWN FILM ON GLASS CARRIER FABRIC.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG LEWIS OR MINERAL ACIDS.
Stability Condition to Avoid:NOT APPLICABLE.
Hazardous Decomposition Products:CO, NO*X, ALDEHYDES, ACIDS AND
UNDETERMINED ORGANICS.
Conditions to Avoid Polymerization:DO NOT EXPOSE ROLLS OF STORED MATL
TO TEMPS IN EXCESS OF 150F UNLESS CURING SURF TO BE BONDED/EXCESS
HEAT (SUPP DATA)
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF AS HAZARDOUS WASTE ACCORDING TO
FEDERAL, STATE, AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ETHANEDIAL (40% SOLUTION IN WATER), 0-230
CAGE:84898
CAGE:84898
CAGE:8Y898
============= Composition/Information on Ingredients =============
Ingred Name:GLYOXAL, 40%; (ETHANEDIAL (40% SOLUTION IN WATER))
CAS:107-22-2
RTECS #:MD2700000
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(RAT) 2020 MG/KG.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ALL CHEMICALS SHOULD BE CONSIDERED
HAZARDOUS - AVOID DIRECT PHYSICAL CONTACT! CAN CAUSE SKIN
IRRITATION. CAN BE IRRITATING TO MUCOUS MEMBRANES. VAPORS &/OR
DIRECT EYE CONTACT CAN CAUSE SEVERE EYE BURN S. THIS COMPOUND IS
CONSIDERED TO BE SLIGHTLY TOXIC.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD IMMED . EYES:FLUSH CONTINUOUSLY W/WATER FOR AT
LST 15-20 MINS. SKIN:FLUSH W/WATER FOR 15-20 MINS. IF NO BURNS HAVE
OCCURRED-USE SOAP & WATER TO CLEANSE SKIN. REMOVE & WASH CONTAM
CLTHG. GET MED ATTN IF NEC. INHAL:REMOVE PATIENT TO FRESH AIR.
ADMIN OXYG IF PATIENT IS HAVING DFCLTY BRTHG. IF PATIENT HAS
STOPPED BRTHG ADMIN ARTF RESP. IF PATIENT IS IN CARDIAC ARREST
ADMIN(SUPDAT)
===================== Fire Fighting Measures =====================
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL POWDER OR WATER SPRAY.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NO EXPLOSION LIMITS ARE AVAILABLE FOR
THIS COMPOUND.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE AREA. WEAR APPROPRIATE OSHA-REGULATED
EQUIPMENT. VENTILATE AREA. ABSORB ON VERMICULITE OR SIMILAR
MATERIAL. SWEEP UP & PLACE IN AN APPROPRIATE CONTAINER. HOLD FOR
DISPOSAL. WASH CONTAMINATED SURFACES TO REMOVE ANY RESIDUES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTACT W/SKIN, EYES & CLOTHING.
KEEP TIGHTLY CLOSED & STORE IN A COOL, DRY PLACE. STORE UNDER
REFRIGERATION. STORE ONLY W/COMPATIBLE CHEMICALS.
Other Precautions:PERSONS NOT SPECIFICALLY & PROPERLY TRAINED SHOULD
NOT HANDLE THIS CHEM/ITS CNTNR. THIS PROD IS FURNISHED FOR LAB USE
ONLY! MFR'S PRODS MAY NOT BE USED AS DRUGS, COSMETICS,
AGRICULTURAL/PESTICIDAL PRO DS, FOOD ADDITIVES/AS HOUSEHOLD CHEMS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:THIS CHEMICAL SHOULD BE HANDLED ONLY IN A HOOD.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . USE APPROPRIATE OSHA/MSHA SAFETY EQUIPMENT.
Work Hygienic Practices:CONTACT LENSES SHOULD NOT BE WORN IN THE
LABORATORY.
Supplemental Safety and Health
FIRST AID PROC:CPR. CONTINUE LIFE SUPPORTING MEASURES UNTIL MEDICAL
ASSISTANCE HAS ARRIVED. NOTE:AN ANTIDOTE IS A SUBSTANCE INTENDED TO
COUNTERACT EFFECT OF A POISON. IT SHOULD BE ADMINISTERED ONLY BY
MD OR TRAINED EMERGENCY PERSONNEL. MEDICAL ADVICE CAN BE OBTAINED
FROM A POISON CONTROL CENTER.
================== Physical/Chemical Properties ==================
Spec Gravity:1.27
Appearance and Odor:YELLOW LIQUID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
INCOMPATIBLE W/STRONG OXIDIZING AGENTS, STRONG ACIDS, STRONG BASES,
STRONG REDUCING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:DECOMPOSITION LIBERATES TOXIC FUMES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS . BURN IN A CHEMICAL INCINERATOR EQUIPPED W/AFTERBURNER
& SCRUBBER.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:DURA-LITH GREASE EP NLGI 2,CPS 254595
CAGE:0ACV2
CAGE:8X116
CAGE:0ACV2
CAGE:0AHD1
============= Composition/Information on Ingredients =============
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATE, SOLVENT DEWAXED (MILD),
HEAVY PARAFFINIC; TOTAL PERCENTAGE OF INGREDIENTS 1 & 2: >85
CAS:64742-65-0
RTECS #:PY8038500
Fraction by Wt: SEE ING
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 AS OIL MIST
ACGIH TLV:5 MG/M3 AS OIL MIST
Ingred Name:MINERAL OIL, HYDROTREATED (MILD), HEAVY NAPHTHENIC
DISTILLATE, PETROLEUM
CAS:64742-52-5
RTECS #:PY8035000
Fraction by Wt: SEE # 1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 AS OIL MIST
ACGIH TLV:5 MG/M3 AS OIL MIST
Ingred Name:LITHIUM BASE THICKENER
Fraction by Wt: <10%
Other REC Limits:NONE RECOMMENDED
Ingred Name:ADDITIVES
Fraction by Wt: <5%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT) IS NOT KNOWN.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYE, SKIN, RESPIRATORY &
GI TRACTS. ACUTE- NOT EXPECTED TO CAUSE PROLONGED OR SIGNIFICANT
EYE IRRITATION. INJECTION UNDER SKIN MAY CAUSE LOCAL NECROSIS. IT
SHOULD BE PRACTICALLY NON-TOXI C TO INTERNAL ORGANS IF INHALED,
INGESTED OR ABSORBED THROUGH SKIN. CHRONIC- UNKNOWN.
Explanation of Carcinogenicity:NONE.
Effects of Overexposure:IRRITATION, REDNESS, TISSUE DAMAGE, NAUSEA
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH PRE-EXISTING SKIN
DISORDERS MAY BE MORE SUCCEPTIBLE TO THE EFFECTS FROM EXPOSURE TO
THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALED:REMOVE TO FRESH
AIR. EYES:FLUSH WITH PLENTY OF WATER. HOLD EYELIDS OPEN. SKIN:WIPE
OFF EXCESS & WASH SKIN WITH MILD SOAP & WATER OR WATERLESS CLEANER.
IFINJECTED UNDER SKIN, REGARDLESS OF ITS SIZE, CONTACT A
PHYSICIAN IMMEDIATELY. DELAY MAY CAUSE LOSS OF AFFECTED PART OF
BODY. ORAL:DO NOT INDUCE VOMITING. IF CONSCIOUS, DRINK WATER/MILK.
CALL PHYSICIAN
===================== Fire Fighting Measures =====================
Flash Point:480F,249C
Extinguishing Media:WATER FOG, CARBON DIOXIDE, SAND, FOAM/DRY CHEMICAL.
WATER SPRAY MAY BE USED TO KEEP FIRE EXPOSED CONTAINERS COOL.
Fire Fighting Procedures:DO NOT ENTER ANY ENCLOSED OR CONFINED AREA
WITHOUT PROPER PROTECTIVE EQUIPMENT AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:TOXIC GASES MAY BE FORMED.
================== Accidental Release Measures ==================
Spill Release Procedures:SCOOP UP EXCESS GREASE. PICK-UP RESIDUE WITH
NON-FLAMMABLE ABSORBENT MATERIAL SUCH AS DIATOMACEOUS EARTH, SAND
OR VERMICULITE. SWEEP UP AND TRANSFER TO A CONTAINER FOR PROPER
DISPOSAL. CLEAN AREA WITH MILD DETERGENT.
Neutralizing Agent:NOT RELEVANT
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY, VENTILATED PLACE
AWAY FROM INCOMPATIBLES. KEEP CONTAINERS TIGHTLY CLOSED. KEEP OUT
OF REACH OF CHILDREN.
Other Precautions:DO NOT GET IN EYES. MINIMIZE SKIN CONTACT. WASH
THOROUGHLY AFTER HANDLING. LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. PROPERLY DISPOSE OF CONTAMINATED LEATHER ARTICLES INCLUDING
SHOES THAT CANNOT BE DECONTAMINATED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY NEEDED. IF WORKING IN CONFINED
AREAS, IF EXCESSIVE MISTING IS EXPECTED OR IF EXPOSURE MAY OR DOES
EXCEED RECOMMENDED PERMISSIBLE EXPOSURE LIMITS, WEAR NIOSH-APPROVED
ORGANIC VAPOR AND MI ST RESPIRATOR (REFER TO 29 CFR 1910.134)
Ventilation:USE ADEQUATE VENTILATION TO KEEP OIL MISTS OF THIS MATERIAL
BELOW APPLICABLE STANDARD(S).
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
INDUSTRIAL-TYPE WORK CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. WASH THOROUGHLY BEFORE EATING,
DRINKING/SMOKING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:V6
NRC/State Lic Num:NOT RELEVANT
Spec Gravity:0.90
Viscosity:12 CST @ 212F
Solubility in Water:INSOLUBLE
Appearance and Odor:SMOOTH AMBER GREASE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS SUCH AS CHLORATES, NITRATES, PEROXIDES ETC.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
OXIDES OF PHOSPHORUS, SULFUR, NITROGEN AND ZINC OXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE
AND FEDERAL REGULATIONS. CONSIDER RECYCLING.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:FORMULA 714 VINYL ADHESIVE
Preparer's Name:WALTER GORBUNOW
CAGE:1FZ63
CAGE:1FZ63
============= Composition/Information on Ingredients =============
Ingred Name:RESIN BLENDS (NOT SPECIFIED)
Fraction by Wt: <23%
Ingred Name:FLEXIBILIZERS
Fraction by Wt: <23%
Ingred Name:TETRAHYDROFURAN
CAS:109-99-9
RTECS #:LU5950000
Fraction by Wt: 46%
Other REC Limits:200 PPM
OSHA PEL:200 PPM
ACGIH TLV:200 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:2-BUTANONE (METHYL ETHYL KETONE) (MEK)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 24%
Other REC Limits:590 MG/CUM
OSHA PEL:200 PPM
ACGIH TLV:200 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:CYCLOHEXANONE, KETOHEXAMETHYLENE
CAS:108-94-1
RTECS #:GW1050000
Fraction by Wt: 5%
Other REC Limits:100PPM (SKIN) STEL
OSHA PEL:200 PPM
ACGIH TLV:200 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:PROCESSING AIDS, VARIOUS
Fraction by Wt: <2%
Ingred Name:STABILIZER
Fraction by Wt: <2%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN: IRRITATION. RESPIRATORY
TRACT IRRITAATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:NAUSEA, DIZZINESS, HEADACHE, IRRITATION,
UNCONSCIOUSNESS, BURNS, DRYNESS, ERYTHEMA
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. GIVE OXYGEN IF NEEDED. EYES:
FLUSH W/COPIOUS AMOUNTS OF WATER. SKIN: WASH W/SOAP & WATER. USE
EMOLLIENT CREAMS. INGESTION: DON'T INDUCE VOMITING. OBTAIN MEDICAL
ATTENT ION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point: 10F
Lower Limits:2.3
Upper Limits:11.8
Extinguishing Media:FOAM, CO2, DRY CHEMICAL
Fire Fighting Procedures:DON'T ENTER CONFINED SPACES W/OUT PROPER
PROTECTIVE EQUIPMENT INCLUDING A NIOSH APPROVED SCBA. USE WATER
SPRAY TO COOL SURFACES & PROTECT PERSONNEL.
Unusual Fire/Explosion Hazard:PEROXIDES ARE EXPLOSIVE. AUTO INGNITION
TEMP: 869F
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE IGNITION SOURCES. ISOLATE ARE &
CLEAN UP W/ABSORBANT MATERIAL. FLUSH W/WATER & COLLECT IN A WASTE
CONTAINER FOR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED & STORE IN A
COOL DRY PLACE. KEEP AWAY FROM HEAT, SPARKS & OPEN FLAMES. GROUND
ALL ELECTRICAL EQUIPMENT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED RESPIRATOR
Ventilation:FACE VELOCITY OF <60FPM IF USED IN CONFINED SPACES.
Other Protective Equipment:USUALLY NOT NEEDED.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:120F
Vapor Pres:114
Vapor Density:2.5
Spec Gravity:0.89
Evaporation Rate & Reference:(ETHER =1): 2.3
Solubility in Water:COMPLETE
Appearance and Odor:THICK CLEAR LIQUID W/ETHER LIKE ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAMES
Hazardous Decomposition Products:CO
==================== Disposal Considerations ====================
Waste Disposal Methods:RECOVER ANY FREE LIQUID W/SUITABLE ABSORBENT.
DISPOSE OF IAW/FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:7224 BLUE 15123 H, 8054813
CAGE:DO804
CAGE:DO804
CAGE:38360
============= Composition/Information on Ingredients =============
Ingred Name:PHOSPHORIC ACID, TRIBUTYL ESTER; (TRIBUTYL PHOSPHATE)
CAS:126-73-8
RTECS #:TC7700000
Fraction by Wt: 20-50%
OSHA PEL:5 MG/M3
ACGIH TLV:0.2 PPM; 9293
Ingred Name:HEXAHYDROPHTHALIC ANHYDRIDE
CAS:85-42-7
Fraction by Wt: 0-5%
Ingred Name:SILANE, 3-(2,3-EPOXYPROPOXY) PROPYLTRIMETHOXY-; (SILANE
A-187)
CAS:2530-83-8
RTECS #:VV4025000
Fraction by Wt: 0-3%
Ingred Name:SPILL PROC: STANDARD: 29 CFR PART 1910.120 HAZARDOUS WASTE
OPERATIONS AND EMERGENCY RESPONSE.
RTECS #:9999999ZZ
Ingred Name:WASTE DISP: RENDER THE RESULTING MATL HAZARDOUS. CONTACT
FEDERAL, STATE AND LOCAL AUTHORITIES FOR DISPOSAL INFO. (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5: CONSULT 40 CFR PART 261 IDENTIFICATION AND LISTING
OF HAZARDOUS WASTE.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC: AND FOR CONTROLLING THE FIRE/EXPLOSION HAZARD.
A QUALIFIED INDEPENDENT TESTING COMPANY CAN DETERMINE (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7: IF THE EXISTING CONCENTRATIONS ARE WITHIN THE
ESTABLISHED RECOMMENDED/PERMISSIBLE EXPOSURE LEVELS.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION, INFLAMMATION. SKIN:
IRRITATION, DERMATITIS. INHAL: DIZZINESS, LOSS OF CONSCIOUSNESS,
IRRITATION, SENSITIZER WITH ASTHMATOID EFFECTS, WHEEZING, COUGHING,
SORE THROAT. INGEST: NAUSEA, VOMITING, ABDOMINAL PAIN.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR @ LST 15 MIN. CALL A PHYSICIAN IMMED.
SKIN: WASH W/SOAP & WATER. LAUNDER CONTAM CLOTHING BEFORE REUSE.
GET MED ATTN. INHAL:REMOVE TO FRESH AIR. ADMINISTER OXYGEN IF
BREATHING I S DIFFICULT. BEGIN RESUSCITATION IF BRTHG HAS STOPPED.
KEEP PERSON WARM & QUIET. GET MEDICAL ATTN. INGEST: DO NOT INDUCE
VOMITING. GET MEDICAL ATTN IMMED. NOTE TO MD: TRIBUTYL PHOSPHATE
(SUPP DATA)
===================== Fire Fighting Measures =====================
Flash Point:>200F,>93C
Extinguishing Media:DRY CHEMICAL, CO*2.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR AND MAY
TRAVEL ALONG THE GROUND AND MAY BE IGNITED AT DISTANT LOCATIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL SOURCES OF IGNITION. ABSORB
SPILLED MATL WITH VERMICULITE OR FLOOR ABSORBENT. DISPOSE OF CONTAM
4)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:CNTNRS OF THESE MATLS MAY BE HAZARDOUS
WHEN EMPTIED, SINCE EMPTIED CNTNRS RETAIN PROD RESIDUES WHICH CAN
GENERATE VAPS WITHIN THE INFLAMMABLE LIMITS.
Other Precautions:FOR FLAMM OR COMBUSTIBLE PRODS FOLLOW STORAGE &
HANDLING GUIDELINES PRESENTED IN NFPA 30 FLAMMABLE & COMBUSTIBLE
LIQUIDS CODE. THE USE OF A HAZARDOUS CHEMICAL MAY REQUIRE
SUPPLEMENTAL VENTILATION FOR THE PROTECTION OF PERSONNEL (ING 7)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SUFFICIENT TO MAINTAIN OPERATOR EXPOSURE BELOW
APPLICABLE OCCUPATIONAL EXPOSURE STANDARDS. ENGINEERING OR
ADMINISTRATIVE CONTROLS OR NIOSH/MSHA APPRVD RESPS CAN BE USED TO
REDUCE EXPOSURE. ENGINEERING CONTROLS ARE PREFERRED BY OSHA.
Ventilation:SUFFICIENT TO MAINTAIN OPERATOR EXPOSURE BELOW APPLICABLE
OCCUPATIONAL EXPOSURE STANDARDS.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRST AID PROC: POSSESSES ONLY WEAK ANTICHOLINESTERASE ACTIVITY WHICH
SHOULD NOT REQUIRE SPECIFIC TREATMENT. LARGE DOSES HAVE BEEN
REPORTED TO CAUSE DYSPNEA, WEAKNESS, PULMONARY EDEMA, AND TWITCHING
I N RATS. CHRONIC INHALATION OF LARGE DOSES CAN LEAD TO GENERAL
POISONING WITH PARALYSIS.
================== Physical/Chemical Properties ==================
Vapor Pres:VERY LOW
Evaporation Rate & Reference:VERY SLOW
Solubility in Water:NEGLIGIBLE
Appearance and Odor:LIQUID OR SEMI-SOLID INK AS COLOR ABOVE, MILD ODOR.
Percent Volatiles by Volume:APPROX
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS AND BASES. WATER.
Stability Condition to Avoid:HEAT AND FLAME.
Hazardous Decomposition Products:CO, CO*2, SILICON OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:UNDER RCRA, IT IS THE RESPONSIBILITY OF THE
GENERATOR OF THE WASTE TO DETERMINE, AT THE TIME OF DISPOSAL,
WHETHER THE WASTE GENERATED MEETS THE FEDERAL OR STATE HAZAROUS
WASTE CRITERIA. USES, TRANSFOR MATIONS, MIXTURES, PROCESSES, ETC.
MAY (ING 5)
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:1,4-DICHLOROBUTANE, O-636
CAGE:84898
CAGE:84898
CAGE:8Y898
============= Composition/Information on Ingredients =============
Ingred Name:1,4-DICHLOROBUTANE
CAS:110-56-5
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: CAN CAUSE EYE AND SKIN
IRRITATION. CAN BE IRRITATING TO MUCOUS MEMBRANES. CAN BE HARMFUL
IF INHALED, SWALLOWED, OR ABSORBED THROUGH THE SKIN. CHRONIC:
PROLONGED EXPOSURE MAY CAUSE NAUSEA, HEADA CHE, DIZZINESS AND/OR
EYE DAMAGE.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:AN ANTIDOTE IS A SUBSTANCE INTENDED TO COUNTERACT EFT OF
POIS. IT SHOULD BE ADMIN ONLY BY MD/TRAINED EMER PERS. MED ADVICE
CAN BE OBTAINED FROM POIS CTL CTR. EYES: FLUSH CONTINUOUSLY W/WATER
FOR AT LE AST 15 MIN. SKIN: FLUSH W/WATER FOR 15-20 MIN. IF NO
BURNS HAVE OCCURRED, USE SOAP & WATER TO CLEANSE SKIN. INHAL:
REMOVE TO FRESH AIR. ADMIN OXYGEN IF DFCLT BRTHG. IF BRTHG HAS
STOPPED, (SUP DAT)
===================== Fire Fighting Measures =====================
Flash Point:104F,40C
Extinguishing Media:USE CARBON DIOXIDE, DRY CHEMICAL POWDER OR WATER
SPRAY.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE AREA. WEAR APPROPRIATE OSHA-REGULATED
EQUIPMENT. VENTILATE AREA. ABSORB ON VERMICULITE OR SIMILAR
MATERIAL. SWEEP UP AND PLACE IN AN APPROPRIATE CONTAINER. HOLD FOR
DISPOSAL. WASH CONTAMINATE D SURFACES TO REMOVE ANY RESIDUES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:ALL CHEMICALS SHOULD BE CONSIDERED
HAZARDOUS. AVOID DIRECT PHYSICAL CONTACT! USE APPROPRIATE OSHA/MSMA
APPROVED SAFETY EQUIPMENT.
Other Precautions:AVOID CONT W/SKIN, EYES, & CLTHG. KEEP TIGHTLY CLSD &
STORE IN COOL DRY PLACE. STORE ONLY W/COMPATIBLE CHEM. PERS NOT
SPECIFICALLY & PROPERLY TRAINED SHOULD NOT HANDLE THIS CHEM/ITS
CONTR. THIS PROD I S FURNISHED FOR LAB USE ONLY! (SUP DAT)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:THIS CHEMICAL SHOULD BE HANDLED ONLY IN A HOOD.
Other Protective Equipment:EMERGENCY EYEWASH & DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA .
Work Hygienic Practices:CONTACT LENSES SHOULD NOT BE WORN IN THE
LABORATORY.
Supplemental Safety and Health
FIRST AID PROC: ADMIN ARTF RESP. IF PATIENT IN CARD ARREST, ADMIN CPR.
CONTINUE LIFE SUPPORTING MEASURES UNTIL MED ASSIST HAS ARRIVED.
OTHER PREC: THIS PROD MAY NOT BE USED AS DRUGS, COSMETICS, AGRICU
LTURAL/PESTICIDAL PRODS, FOOD ADDITIVES/AS HOUSEHOLD CHEMICALS.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:325F,163C
Melt/Freeze Pt:M.P/F.P Text:-98F,-72C
Spec Gravity:1.160
Appearance and Odor:COLORLESS LIQUID, WITH ETHER-LIKE ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
INCOMPATIBLE WITH STRONG OXIDIZING AGENTS, STRONG BASES.
Stability Condition to Avoid:FLAMMABLE.
Hazardous Decomposition Products:DECOMPOSITION LIBERATES TOXIC FUMES.
DECOMPOSITION PRODUCTS ARE CORROSIVE.
==================== Disposal Considerations ====================
Waste Disposal Methods:BURN IN A CHEMICAL INCINERATOR EQUIPPED WITH AN
AFTERBURNER AND SCRUBBER. DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS .
| 1 | gloves_mandatory |
=======================================================
Product ID: BONDSEAL, FE-1407-A
Kit Part: Y
Cage: GO965
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 0DH19
Cage: GO965
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: YES
IARC: YES
OSHA: NO
Effects of Exposure: ACUTE:EYES:DIRECT CONTACT W/PRODUCT MAY CAUSE IRRITATION.
SKIN:EPOXY RESINS ARE POTENTIAL DERMAL SENSITIZERS. INHALATION:INHALATION IS
NOT A ROUTE OF EXPOSURE. CHRONIC:THIS PRODUCT IS NOT ANTICIPATED TO CAUSE
ANY CHRONIC EFFECTS. ONCE PRODUCT IS IN ITS FINAL FORM & IS ABRADED OR
DISTURBED, DUSTING MAY (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: SEE "LR" VERSION FOR ADDITIONAL INFORMATION
(FP N).
Signs And Symptions Of Overexposure: HLTH HAZ:BE RELEASED INTO AIR. LONG-TERM
OVEREXPOSURE TO CRYSTALLINE SILICA MAY CAUSE PERMANENT LUNG DAMAGE &
REDUCED PULMONARY FUNCTION.
Medical Cond Aggravated By Exposure: NO KNOWN EFFECTS ON OTHER ILLNESSES.
First Aid: INGEST:CALL MD IMMEDIATELY (FP N). INHAL:REMOVE TO FRESH AIR.
SUPPORT BREATHING (GIVE O*2/ARTF RESP) (FP N). EYES:FLUSH IMMEDIATELY W/WATER
FOR AT LEAST 15 MINUTES. CONSULT MD IF IRRITATION PERSISTS. SKIN:WASH
AFFECTED AREA W/SOAP & WATER.LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
=======================================================
Handling and Disposal
=======================================================
MATERIAL. RESIDUE MAY BE REMOVED W/CHLORINATED SOLVENT.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISP MUST BE I/A/W FED, STATE & LOC REGS (FP N). TO
THE BEST OF MFR'S KNOWLEDGE, THIS PROD DOES NOT BEEN DEFINITION OF HAZ WASTE
UNDER U.S. EPA HAZ WASTE REGS 40 CFR 261. IT DOES NOT CONTAIN ANY ADDED RAW
MATLS W/KNOWN LEVELS OF TCLP (SUPPDATA)
Handling And Storage Precautions: STORE IN A COOL, DRY LOCATION.
Other Precautions: POTENTIAL DERMAL SENSITIZER. AVOID SKIN CONTACT W/PRODUCT AT
ALL TIMES. DURING NORMAL USE MATERIAL WILL NOT PRESENT AN EXPOSURE RISK. ONCE
PROD HAS REACHED ITS FINAL STATE & IS ABRADED/DISTURBED, DUST ING &
EXPOSURE MAY OCCUR.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: SCC
Flash Point Text: >400F,>204C
Extinguishing Media: USE WATER SPRAY, FOAM, DRY CHEMICAL OR CARBON DIOXIDE.
Fire Fighting Procedures: USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: NONE KNOWN.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE
OF CONCERN (FP N). NOT NORMALLY REQUIRED.
Ventilation: STANDARD INDUSTRIAL VENTILATION.
Other Protective Equipment: EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET ANSI
DESIGN CRITERIA (FP N). PREVENT CONT BY USING APPROP PROT CLOTHING.
Work Hygienic Practices: LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health: NOTE:USERS OF "L" VERSION SHOULD CONSULT "LR"
VERSION FOR ADDITIONAL INFO (FP N). WASTE DISP METH:CONSTITUENTS AS
IDENTIFIED IN SECTION 261.24 OF U.S. EPA HAZ WASTE REGS. LEACHATE TESTS HAVE
NOT BEEN PERFORMED. STATE/LOC REGS MAY APPLY IF THEY ARE DIFF FROM FED REG.
INCIN/DISPOSE OF IN APPRVD
=======================================================
Physical/Chemical Properties
=======================================================
Spec Gravity: 1.44 (FP N)
Appearance and Odor: LIQUID.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: NOT ESTABLISHED.
Hazardous Decomposition Products: INCOMPLETE COMBUSTION CAN YIELD LOW MOLECULAR
WEIGHT HYDROCARBONS, CARBON MONOXIDE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: BONDSEAL, FE-1407-A
Cage: GO965
Assigned IND: Y
Company Name: HB FULLER CO
Street: 1200 WOLTERS BLVD
Zipcode: 55110
Label Required IND: Y
Date Of Label Review: 01/18/1996
Status Code: C
Label Date: 01/18/1996
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Moderate
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: ACUTE:EYES:DIRECT CONTACT WITH PRODUCT MAY CAUSE
IRRITATION. SKIN:EPOXY RESINS ARE POTENTIAL DERMAL SENSITIZERS.
INHALATION:INHALATION IS NOT A ROUTE OF EXPOSURE. CHRONIC:CANCER HAZARD.
CONTAINS MATER IAL LISTED AS AN ANIMAL LUNG CARCINOGEN(FP N). THIS PRODUCT IS
NOT ANTICIPATED TO CAUSE ANY CHRONIC EFFECTS. ONCE PRODUCT IS IN ITS FINAL
FORM AND IS ABRADED OR DISTURBED, DUSTING MAY OCCUR AND CRYSTA LLINE SILICA
MAY BE RELEASED. LONG TERM OVEREXPOSURE MAY CAUSE PERMANENT LUNG DAMAGE AND
REDUCED PULMONARY FUNCTION.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:70430006 1 GAL, SELECTRON ACTIVATOR 2 (SUP DAT)
Preparer's Name:WERNER A EHRENSCHNEIDER
CAGE:FO860
CAGE:FO860
CAGE:11924
============= Composition/Information on Ingredients =============
Ingred Name:HYDROGEN CHLORIDE (HYDROCHLORIC ACID) (SARA 302/313)
(CERCLA)
CAS:7647-01-0
RTECS #:MW4025000
Fraction by Wt: <6%
OSHA PEL:C 5 PPM
ACGIH TLV:C 5 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: >94%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUP DAT: CALM & REASSURE HIM. EYE: HOLDING EYELIDS APART &
MOVING EYES SLOWLY IN EVERY DIRECTION, IMMED FLUSH W/ (ING 4)
RTECS #:9999999ZZ
Ingred Name:ING 3: PLENTY OF TEPID WATER FOR AT LEAST 15 MIN. SKIN:
IMMED FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MIN WHILE (ING 5)
RTECS #:9999999ZZ
Ingred Name:ING 4: REMOVING CONTAM CLTHG & SHOES AS QUICKLY AS POSS.
INHAL: REMOVE TO FRESH AIR. LAY VICTIM DOWN, LEGS (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5: RAISED. LOOSEN TIGHT CLTHG. COVER W/BLANKET. IF NOT
BRTHG, GIVE ARTF RESP. IF BRTHG IS DFCLT, GIVE LOW (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6: PRESS OXYGEN. INGEST: DO NOT INDUCE VOMIT. IMMED
GIVE LGE QTYS OF WATER/MILK. IF VOMIT OCCURS, GIVE FLUIDS(ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7: REPEATEDLY. NEVER GIVE ANYTHING BY MOUTH TO AN UNCON
PERS. CHRONIC OVEREXP: REMOVE FROM FURTHER EXPOSURE.
RTECS #:9999999ZZ
Ingred Name:SPILL PROC: SHIP TO APPROVED TREATMENT/DISPOSAL FACILITY.
FLUSH SPILL AREA WITH PLENTY OF WATER.
RTECS #:9999999ZZ
Ingred Name:RESP PROT: ANY SUPP-AIR RESP W/FULL FACEPIECE, ANY SCBA
W/FULL FACEPIECE, ANY AIR-PURIFYING FULL-FACEPIECE RESP (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10: (GAS) W/ACID GAS CANISTER(S), ANY CHEM CARTRIDGE
RESP W/FULL FACEPIECE ACID GAS CARTRIDGES, ANY POWERED (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11: AIR-PURIFYING RESP W/ACID GAS CARTRIDGES.
EMER/PLANNED ENTRY IN UNKNOWN CONC/IDLH CNDTNS: USE ANY SCBA (ING
13)
RTECS #:9999999ZZ
Ingred Name:ING 12: W/FULL FACEPIECE & OPERATED IN PRESS-DEMAND
MODE/OTHER POS-PRESS MODE, ANY SUPP-AIR RESP W/FULL (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13: FACEPIECE & OPERATED IN PRESS-DEMAND/OTHER
POS-PRESS MODE IN COMBINATION W/AUXILIARY SCBA OPERATED IN (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14: PRESS-DEMAND/OTHER POS-PRESS MODE. ESCAPE: USE ANY
AIR-PURIFYING FACEPIECE RESP (GAS MASK) W/ACID GAS (ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15: CANISTER(S), ANY APPROPRIATE ESCAPE-TYPE SCBA.
RTECS #:9999999ZZ
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS: RESP SYS, SKIN, EYES.
ACUTE: WARNING! MAY CAUSE EYE, SKIN & RESP IRRIT. EYE: PAIN,
TEARING, IRRIT, INFLAMM. SKIN: IRRIT, INFLAMM. INHAL: SNEEZING,
COUGHING, CHOKING, HDCH, DIZZ, WEAK, T IGHTNESS IN CHEST, AIR
HUNGER. INGEST: SALTY BITTER TASTE IN MOUTH, STRONG SALIVATION,
IRRIT OF TISS (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: IN MOUTH & THROAT, HEART BURN, NAUS,
VOMIT. CHRONIC: EROSION OF TEETH, JAW NECROSIS, BRONCHIAL IRRIT,
CHRONIC COUGH, BRONCHIAL PNEUMONIA, GI DISTURBANCES ARE POSS.
Medical Cond Aggravated by Exposure:PREEXISTING RESPIRATORY, EYE AND
SKIN CONDITIONS.
======================= First Aid Measures =======================
First Aid:FIRST AIDERS MUST TAKE PREC FOR THEIR OWN SFTY BEFORE
ENTERING CONTAM AREAS TO ASSIST CHEM ACCIDENT VICTIMS & HNDLG
CONTAM CLTHG & EQUIP. ALWAYS HAVE ANOTHER PERS IMMED CALL EMER MED
SERVICE, POIS CTL CTR, 911-OPERATOR, HOSPITAL, MD/OPHTHALMOLOGIST
DESCRIPTION OF ACCIDENT, NAME OF CHEM AGENTS & PROD, # & CNDTN OF
(SUP DAT)
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:NONE
Upper Limits:NONE
Extinguishing Media:ALL. USE MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:EXCESSIVE HEAT MAY CAUSE CONTAINERS TO
BURST AND GENERATE CORROSIVE VAPORS. CONTACT WITH COMMON METALS MAY
GENERATE FLAMMABLE HYDROGEN GAS.
================== Accidental Release Measures ==================
Spill Release Procedures:NOTIFY YOUR FACILITY EMER COORDINATOR. DO NOT
RELEASE INTO SOIL, SEWER, STREAM, POND/SOURCES OF DRINKING WATER.
PROVIDE MAX VENT. ELIM ALL SOURCES OF IGNIT. CAREFULLY MOP
UP/VACUUM SPILL & TRIPLE RINS E WATER INTO SUITABLE PLASTIC CONTRS.
(ING 9)
Neutralizing Agent:SODIUM BICARBONATE, SODA ASH/SLAKED LIMESTONE.
======================Handling and Storage ======================
Handling and Storage Precautions:USE "BUDDY SYS" WHEN WORKING W/CHEMS.
DO NOT GET IN EYES, ON SKIN/CLTHG. AVOID BRTHG VAP, MIST/GAS. USE
W/ADEQ VENT.
Other Precautions:KEEP CONTR CLSD IN UPRIGHT POSITION. STORE AT 50-90F
AWAY FROM INCOMPATIBLE MATLS. PROTECT CONTRS AGAINST PHYSICAL
INJURY. DO NOT REMOVE/DEFACE CONTR LABELS. TRIPLE RINSE CONTR CLEAN
BEFORE DISCARDING . PUT NOTHING ELSE IN THIS CONTAINER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPRVD RESP PROT REQUIRED. HYDROCHLORIC
ACID: <50 PPM: USE ANY SUPP-AIR RESP, ANY SCBA, ANY CHEM CARTRIDGE
RESP W/ACID GAS CARTRIDGE. <100 PPM: USE ANY SUPP-AIR RESP W/TIGHT
FITTING FACEPIECE OP ERATED IN CONTINUOUS FLOW MODE, (ING 10)
Ventilation:LOCAL EXHAUST REQUIRED TO MEET PERMISSIBLE EXPOSURE LIMITS
(PEL).
Other Protective Equipment:ANSI APPROVED EMERGENCY EYEWASH & DELUGE
SHOWER . IMPERVIOUS BOOTS, APRON, PROTECTIVE CLOTHING AS REQUIRED.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. DO NOT WEAR
CONTACT LENSES.
Supplemental Safety and Health
TRADE NAME/PART #: SOLUTION, SCM 4300. SPEC GRAV: 1.083-1.093 (H*2O=1).
FIRST AID PROC: CASUALTIES, WHAT IS BEING DONE FOR VICTIMS. STAY ON
FIRST AID TO VICTIM. TIME IS VITALLY IMPORTANT. REMOVE VICTIM FROM
CONTAM AREA TO CLEAN, QUIET, VENTD AREA. (ING 3)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>212F,>100C
Melt/Freeze Pt:M.P/F.P Text:<32F,<0C
Spec Gravity:SUP DAT
pH:0-1
Evaporation Rate & Reference:SLOWER THAN ETHYL ETHER
Solubility in Water:COMPLETE
Appearance and Odor:LIGHT YELLOW LIQUID, PUNGENT ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
METALS, STRONG BASES AND ACIDS, OXIDIZERS.
Stability Condition to Avoid:NOT APPLICABLE.
Hazardous Decomposition Products:HCL, CL*2, NA*2O.
==================== Disposal Considerations ====================
Waste Disposal Methods:SHIP TO APPROVED TREATMENT/DISPOSAL FACILITY.
DISPOSE OF ACCORDING TO LOCAL, STATE AND FEDERAL REGULATIONS. EPA
WASTE NUMBER: D002. REPORTABLE QUANTITY: > 38,000 QUARTS, > 9,500
GALLONS.
| 1 | gloves_mandatory |
=======================================================
NIIN: 01-466-1647
Product ID: SKY WASH
Cage: KA861
Country: UK
=======================================================
Contractor Summary
=======================================================
Cage: KA861
Country: UK
=======================================================
Item Description Information
=======================================================
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE
Effects of Exposure: NONE
Signs And Symptions Of Overexposure: NONE
Medical Cond Aggravated By Exposure: NONE
First Aid: EYES: IRRIGATE WITHWATER FOR AT LEAST 15 MINUTES. SKIN: RINSE
CONTAMINATED AREA WITH PLENTY OF WATER. INGESTION: WASH OUT MOUTH WITH WATER,
GIVE PLENTY OF WATER TO DRINK.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: WASH TO DRAIN WITH PLENTY OF WATER. WEAR RUBBER
Neutralizing Agent: NONE
Waste Disposal Methods: DISPOSE OF THROUGH AN AUTHORIZED CONTRACTOR TO A
LANDFILL SITE.
Handling And Storage Precautions: AVOID EYE CONTACT: STORAGE: STORE IN
ORIGINAL CONTAINERS. AVOID EXTREMES OF TEMPERATURES.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: NONE
Autoignition Temp Text: NONE
Lower Limits: NONE
Upper Limits: NONE
Extinguishing Media: NON COMBUSTIBLE MATERIAL
Fire Fighting Procedures: NONE
Unusual Fire/Explosion Hazard: NONE
=======================================================
Control Measures
=======================================================
Respiratory Protection: NONE
Ventilation: NONE
Other Protective Equipment: NONE
Work Hygienic Practices: NONE
Supplemental Safety and Health: NONE
=======================================================
Physical/Chemical Properties
=======================================================
Boiling Point: =100.C, 212.F
Melt/Freeze Pt: =0.C, 32.F
Decomp Text: NONE
Vapor Pres: AS WATER
Vapor Density: 1.01
PH: 6TO7 ABLE
Viscosity: THIN
Evaporation Rate & Reference: SLOW
Solubility in Water: COMPLETELY SOLUBLE
Appearance and Odor: CLEAR LIQUID MILD
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: EXTREMES OF TEMPERATURE.
Materials To Avoid: NONE
Hazardous Decomposition Products: OXIDES OF CARBON.
Conditions To Avoid Polymerization: NONE
=======================================================
HAZCOM Label
=======================================================
Product ID: SKY WASH
Cage: KA861
Company Name: ELIXAIR INTERNATIONAL LIMITED
Street: UNIT F2 ROMAN HILL TRADING ESTATE BROADMAYNE
Zipcode: 00000
Country: UK
Label Required IND: Y
Date Of Label Review: 10/05/2001
Status Code: A
Origination Code: G
Hazard And Precautions: NONE
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TURBINE FUEL, AVIATION JP-5
CAGE:0AHD1
CAGE:0AHD1
============= Composition/Information on Ingredients =============
Ingred Name:DISTILLATE, WIDE BOILING RANGE; ALIPHATIC AND AROMATIC
Fraction by Wt: >75%
Other REC Limits:NONE SPECIFIED
Ingred Name:HEXANE (N-HEXANE)
CAS:110-54-3
RTECS #:MN9275000
Fraction by Wt: <25%
Other REC Limits:NONE SPECIFIED
OSHA PEL:500 PPM
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:BENZENE (SARA III)
CAS:71-43-2
RTECS #:CY1400000
Fraction by Wt: <.1%
Other REC Limits:NONE SPECIFIED
OSHA PEL:1PPM/5STEL;1910.1028
ACGIH TLV:10 PPM; A2; 9192
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:ETHYL BENZENE (SARA III)
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: 0.1%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM/125 STEL
ACGIH TLV:100 PPM/125STEL 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: <.3%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: <.1%
Other REC Limits:NONE SPECIFIED
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:THIS PRODUCT IS NOT EXPECTED TO CAUSE
PROLONGED OR SIGNIFICANT EYE OR SKIN IRRITATION. PROLONGED
BREATHING OF VAPORS CAN CAUSE CENTRAL NERVOUS SYSTEMS EFFECTS. IF
INGESTED, IT IS PRACTICALLY NON-TOXIC , BUT BECAUSE OF ITS LOW
VISCOSITY, IT CAN DIRECTLY ENTER THE LUNGS & CAN CAUSE SEVERE
INJURY TO THE LUNGS OR DEATH.
Explanation of Carcinogenicity:NONE OF THE CHEMICALS IN THIS PRODUCT IS
LISTED BY IARC, NTP OR OSHA AS A CARCINOGEN.
Effects of Overexposure:INHALATION-HEADACHE, DIZZINESS, LOSS OF
APPETITE, WEAKNESS AND LOSS OF COORDINATION INGESTION-IF ASPIRATED
IT CAN CAUSE DEATH.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE-FLUSH WITH WATER FOR 15 MINUTES. SKIN-REMOVE CONTAMINATED
CLOTHES. WASH WITH SOAP AND WATER. SEE A DOCTOR. INHALATION-REMOVE
TO FRESH AIR. SEE A DOCTOR IF SYMPTOMS OCCUR. INGESTION-DO NOT
INDUCE V OMITING. GIVE WATER OR MILK TO DRINK. GET MEDICAL
ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:140F,60C
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:DO NOT ENTER ENCLOSED AREA WITHOUT PROTECTIVE
EQUIPMENT AND A SELF CONTAINED BREATHING APPARATUS TO PROTECT
AGAINST DECOMPOSITION PRODUCTS OR OXYGEN DEPLETION.
Unusual Fire/Explosion Hazard:LIQUID EVAPORATES & FORM VAPOR/FUMES
WHICH CAN IGNITE & BURN WITH EXPLOSIVE VIOLENCE. UNSEEN VAPORS CAN
SPREAD & IGNITE IN OTHER AREAS. HAZARD IS > ABOVE 85F.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL OPEN FLAMES. STOP THE SOURCE OF
THE LEAK OR RELEASE. CLEAN UP SPILL AS SOON AS POSSIBLE, OBSERVING
PRECAUTIONS IN PROTECTIVE EQUIPMENT. CLEAN UP SMALL SPILL USING
APPROPIATE TECHNIQUES S UCH AS SORBENT MATERIALS OR PUMPING.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT USE OR STORE NEAR FLAME, SPARKS
OR HOT SURFACES. USE ONLY IN WELL VENTED AREA. KEEP CONTAINER
CLOSED. DO NOT WELD, HEAT OR DRILL CONTAINER.
Other Precautions:EMPTIED CONTAINER STILL CONTAINS HAZARDOUS OR
EXPLOSIVE VAPOR OR LIQUID. CAUTION! DO NOT USE PRESSURE TO EMPTY
DRUM OR EXPLOSION MAY RESULT. WARNING! NOT FOR USE AS PORTABLE
HEATER OR APPLIANCE FUEL. TOXIC FUMES MAY ACCUMULATE & CAUSE DEATH
============= Exposure Controls/Personal Protection =============
Respiratory Protection:THIS MATERIAL MAY BE AN INHALATION HAZARD &,
UNLESS VENTILATION IS ADEQUATE, THE USE OF AN APPROVED RESPIRATOR
IS RECOMMENDED. REFER TO THE OSHA BENZENE STANDARD TO DETERMINE
WHAT TYPE OF RESPIRATOR I S REQUIRED BASED ON EXPOSURE LEVELS.
Ventilation:USE THIS MATERIAL ONLY IN WELL VENTILATED AREAS.
Other Protective Equipment:SAFETY SHOWER AND EYE BATH. INDUSTRIAL TYPE
WORK CLOTHING IS REQUIRED TO AVOID PROLONGED OR REPEATED CONTACT.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING AND BEFORE
EATING OR DRINKING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:365F,185C
Vapor Pres:0.04
Spec Gravity:0.82
Solubility in Water:INSOLUBLE
Appearance and Odor:PALE YELLOW LIQUID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MAY REACT WITH STRONG OXIDIZING AGENTS, SUCH AS CHLORATES, NITRATES,
PEROXIDES, ETC.
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES AND OTHER SOURCES
OF IGNITION.
Hazardous Decomposition Products:NORMAL COMBUSTION FORMS CARBON DIOXIDE
AND WATER VAPOR; INCOMPLETE COMBUSTION CAN PRODUCE CARBON MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:PLAVE CONTAMINATED MATERIALS IN DISPOSABLE
CONTAINERS AND DISPOSE OF IN A MANNER CONSISTENT WITH APPLICABLE
REGULATIONS. CONTACT LOCAL ENVIRONMENTAL OR HEALTH AUTHORITIES FOR
APPROVED DISPOSAL OF THIS MATERIAL.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:FLEX PRIME WHITE, 2333
Preparer's Name:J BURNWORTH
CAGE:9H480
CAGE:9H480
============= Composition/Information on Ingredients =============
Ingred Name:ETHYLENE GLYCOL. VP:0.1 @ 68F.
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: 2.78%
OSHA PEL:50 PPM,C
ACGIH TLV:50 PPM,C
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SILICA, CRYSTALLINE - QUARTZ (SILICON DIOXIDE)
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 3%
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHAL:INHAL OF HIGH CONCENTRATIONS OF
VAPORS MAY CAUSE HEADACHE, NAUSEA AND IRRITATION OF NOSE, THROAT
AND LUNGS. SKIN: REPEATED LIQUID CONTACT MAY CAUSE IRRITATION AND
DERMATITIS. EYE:MAY CAUSE IRRIT ATION OR BURNING. INGEST:SWALLOWING
CANCAUSE GI IRRITATION, NAUSEA, VOMITING AND DIARRHEA. VOMITING
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:SILICA, CRYSTALLINE:GROUP 2A (IARC)
Effects of Overexposure:HLTH HAZ:CAN RESULT IN ASPIRATION OF MATERIAL
INTO LUNGS WHICH CAN CAUSE CHEMICAL PNEUMONITIS. ACUTE:(SHORT TERM)
OVEREXPOSURE MAY CAUSE HEADACHE, NAUSEA, SKIN AND EYE IRRITATION.
CHRONIC:(LONG TERM) UNPROTECTED OVEREXPOSURE TO MISTS FROM SPRAY
APPLICATION MAY CAUSE LUNG DISEASE (SILICOSIS).
Medical Cond Aggravated by Exposure:NONE KNOWN AT THIS TIME.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. IF BREATHING HAS STOPPED, APPLY
ARTIFICIAL RESPIRATION. CALL MD. EYE:WASH WITH CLEAN WATER FOR AT
LEAST 15 MINUTES. CALL MD. SKIN:WASH AFFECTED AREAS WITH SOAP &
WATER. REMO VE CONTAMINATED CLOTHING. CALL MD. INGEST:DRINK 1 OR 2
GLASSES OF WATER TO DILUTE. CALL MD OR POISON CONTROL CENTER
IMMEDIATELY.
===================== Fire Fighting Measures =====================
Lower Limits:3.2%
Upper Limits:15.2%
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMCIAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:WATER MAY BE USED TO COOL CLOSED
CONTAINERS TO PREVENT PRESSURE BUILD UP AND EXPLOSION WHEN EXPOSED
TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. PREVENT SKIN AND EYE CONTACT
AND BREATHING OF VAPOR. CONTAIN AND REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 200F.
Other Precautions:DO NOT TAKE INTERNALLY. KEEP OUT OF REACH OF
CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED FOR BRUSH AND ROLL APPLICATION. FOR
SPRAY APPLICATION, WEAR A PROPERLY FITTED NIOSH/MSHA (TC-23C)
APPROVED VAPOR/PARTICLUATE RESPIRATOR UNTIL ALL VAPORS AND SPRAY
MISTS ARE EXHAUSTED.
Ventilation:PROVIDE SUFFICIENT VENT IN VOLUME/PATTERN TO KEEP AIR
CONTAM CONC BELOW APPLIC OSHA PEL/ACGIH OCCUPATIONAL EXPOS LIMITS.
SPARY APPLICATION. PROTECTIVE CREAMS FOR CLEAN-UP, NOT PROTECTION.
Work Hygienic Practices:WASH HANDS BEFORE EATING OR USING THE RESTROOM.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:T6
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:SEE ING 1
Vapor Density:LTR/AIR
Spec Gravity:1.3
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:DILUTABLE
Appearance and Odor:WHITE COLORED LIQUID WITH AMMONIACAL ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN AT THIS TIME.
Stability Condition to Avoid:DO NOT HEAT ABOVE 200F.
Hazardous Decomposition Products:NONE KNOWN AT THIS TIME.
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT ALLOW MATERIAL TO CONTAMINATE WATER
SYSTEMS. ABSORB LARGE SPILLS WITH SAND, CLAY, OR DIATOMACEOUS
EARTH. DISPOSE IN ACCORDANCE WITH LOCAL, STATE, AND FEDERAL
DISPOSAL REQUIREMENTS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PHILLYCLAD SOLVENT PRS 59
CAGE:ITWPH
CAGE:20420
CAGE:ITWPH
============= Composition/Information on Ingredients =============
Ingred Name:2-PROPANOL, 1-METHOXY-; (PROPYLENE GLYCOL MONOMETHYL ETHER)
CAS:107-98-2
RTECS #:UB7700000
Fraction by Wt: > 60%
OSHA PEL:100 PPM;150 PPM STEL
ACGIH TLV:100 PPM;150 PPM STEL
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50: (ORAL,RAT) 5660 MG/KG (ING 1)
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN: MODERATE IRRITANT. INHAL:
IRRITATION OF RESPIRATORY TRACT, HEADACHES, DIZZINESS AND NAUSEA.
INGEST: SIMILAR TO INHALATION. CHRONIC: REPEATED EXCESSIVE SKIN
CONTACT MAY CAUSE DERMATITIS. OVE REXPOSURE TO SOLVENTS ABOVE THEIR
TLV'SMAY CAUSE LIVER AND KIDNEY DISORDERS.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NONE.
======================= First Aid Measures =======================
First Aid:EYES: IMMED FLUSH W/LRG AMTS OF H*2O FOR @ LST 15 MIN WHILE
HOLDING EYELIDS OPEN. CONSULT A PHYSICIAN. SKIN: REMOVE
CONTAMINATED CLOTHING & WASH W/SOAP & WATER. CONSULT A PHYSICIAN IF
IRRITATION PERSI STS. INHAL: REMOVE TO FRESH AIR. RESTORE
RESPIRATION IF NECESSARY. INGEST: DO NOT INDUCE VOMITING. DRINK 1-2
GLASSES OF WATER TO DILUTE. KEEP HEAD BELOW HIPS TO PVNT ASPIR INTO
LUNGS. SEEK PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:89.0F,31.7C
Lower Limits:3 %
Upper Limits:12 %
Extinguishing Media:CO*2, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:FIREFIGHTERS SHOULD WEAR NIOSH/MSHA APPROVED
SCBA AND FULL PROTECTIVE EQUIPMENTTO AVOID INHALATION OF SMOKE OR
VAPORS.
Unusual Fire/Explosion Hazard:CONTAINS FLAMMABLE SOLVENT. DO NOT USE IN
AREA WHERE SPARKS OR OPEN FLAMES ARE PRESENT.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES. CONTAIN SPILL
WITH ABSORBENT MATERIAL AND PUT INTO VAPOR TIGHT CONTAINERS.
PREVENT MATERIAL FROM CONTACTING ANY WATER SOURCES OR SEWAGE
SYSTEMS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN AREAS DESIGNED TO COMPLY
W/ANSI/NFPA 30 FLAMMABLE/COMBUST LIQS CODE. DO NOT HANDLE UNTIL
MFR'S SAFETY PREC HAVE BEEN READ AND UNDERSTOOD.
Other Precautions:PROVIDE ADEQUATE VENTILATION OR RESPIRATORY
PROTECTION TO REMOVE DECOMPOSITION PRODUCTS DURING WELDING OR FLAME
CUTTING COATED SURFACES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IN CONFINED AREAS, USE NIOSH/MSHA APPROVED
RESPIRATOR.
Ventilation:GOOD GENERAL VENT IS USUALLY ADEQ FOR MOST INDUST
APPLICATIONS. LOCAL EXHAUST SHOULD BE USED IN CONFINED AREAS.
Other Protective Equipment:LONG SLEEVE CLOTHING.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:243F,117C
Vapor Density:> 1
Spec Gravity:0.9
Evaporation Rate & Reference:0.7 (BUTYL ACETATE=1)
Solubility in Water:NIL
Appearance and Odor:CLEAR LIQUID WITH ETHEREAL ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OIXIDIZING AGENTS, STRONG ACIDS AND BASES.
Stability Condition to Avoid:EXTREME HEAT, SPARKS AND OPEN FLAMES.
Hazardous Decomposition Products:MAY FORM CO*2 AND NITROGEN OXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE AND
LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SODIUM DIETHYLDITHIOCARBAMATE
CAGE:23104
CAGE:23104
CAGE:62910
============= Composition/Information on Ingredients =============
Ingred Name:CARBAMIC ACID, DIETHYLDITHIO-, SODIUM SALT, TRIHYDRATE;
(SODIUM DIETHYLDITHIOCARBAMATE (HYDRATED))
CAS:20624-25-3
RTECS #:EZ6550000
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CARBAMIC ACID, DIETHYLDITHIO-, SODIUM SALT; (SODIUM
DIETHYLDITHIOCARBAMATE (ANHYDROUS))
CAS:148-18-5
RTECS #:EZ6475000
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50: (ORAL, RAT) 1500 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: DUSTS ARE CAUSTIC TO
MUCOUS MEMBRANES. INGESTION: MODERATELY TOXIC. CAUSTIC TO DIGESTIVE
TRACT. SKIN CONTACT: MILDLY IRRITATING TO SKIN UPON CONTINUED
EXPOSURE. EYE CONTACT: IRRITATING TO EYE TISSUES BECAUSE OF
ALKALINITY. CHRONIC: NO INFORMATION FOUND.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NO INFORMATION FOUND.
======================= First Aid Measures =======================
First Aid:INHAL: IF INHALED, REMOVE TO FRESH AIR. IF NOT BREATHING,
GIVE ARTF RESP. IF BREATHING IS DIFFICULT, GIVE OXYGEN. CALL MD.
INGEST: IF SWALLOWED, INDUCE VOMITING IMMED BY GIVING TWO GLASSES
OF WATER, O R MILK IF AVAIL, & STICKING FINGER DOWNTHROAT. CALL MD
IMMED. NEVER GIVE ANYTHING BY MOUTH TO UNCON PERSON. SKIN: REMOVE
ANY CONTAMD CLTHG. WASH SKIN W/SOAP OR MILD DETERGENT & WATER FOR
AT (SUPDAT)
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER SPRAY, DRY CHEMICAL, ALCOHOL FOAM OR CARBON
DIOXIDE.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:AS WITH MOST ORGANIC SOLIDS, FIRE IS
POSSIBLE AT ELEVATED TEMPERATURES OR BY CONTACT WITH AN IGNITION
SOURCE. NOT CONSIDERED TO BE AN EXPLOSION HAZARD.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA OF LEAK OR SPILL. CLEAN-UP
PERSONNEL REQUIRE PROTECTIVE CLOTHING AND NIOSH APPROVED
RESPIRATORY PROTECTION FROM DUST. SPILLS: PICK UP AND PLACE IN
SUITABLE CONTAINER FOR RECLAMATION OR DISPOSAL IN METHOD THAT DOES
NOT GENERATE DUST.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP IN TIGHTLY CLOSED CONTAINER.
STORE IN A COOL, DRY, VENTILATED AREA AWAY FROM SOURCES OF
IGNITION. PROTECT AGAINST PHYSICAL DAMAGE.
Other Precautions:AVOID BREATHING DUST. KEEP CONTAINER CLOSED. USE WITH
ADEQUATE VENTILATION. WASH THOROUGHLY AFTER HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOR CONDITIONS OF USE WHERE EXPOSURE TO THE DUST
IS APPARENT, A NIOSH APPROVED DUST/MIST RESPIRATOR MAY BE WORN. FOR
EMERGENCIES, A NIOSH APPROVED SELF-CONTAINED BREATHING APPARATUS
MAY BE NECESSARY.
Ventilation:LOCAL EXHAUST SYSTEM WHICH CAPTURES THE CONTAMINANT AT ITS
SOURCE IS RECOMMENDED TO PREVENT DISPERSION OF THE (SUPDAT)
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER . LAB
COAT, APRON OR COVERALLS.
Work Hygienic Practices:CONTACT LENSES SHOULD NOT BE WORN WHEN WORKING
WITH THIS MATERIAL.
Supplemental Safety and Health
CNDTNS (STAB): DUE TO LIBERATION OF CARBON DISULFIDE. FIRST AID PROC:
LEAST 15 MIN. GET MED ATTN IF IRRITATION DEVELOPS OR PERSISTS.
EYES: WASH EYES W/PLENTY OF WATER FOR AT LEAST 15 MIN. CALL MD. VEN
T: CONTAMINANT INTO THE WORKROOM AIR.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:203F,95C
Spec Gravity:1.1
Solubility in Water:FREELY SOLUBLE
Appearance and Odor:WHITE OR SLIGHTLY BROWN OR SLIGHTLY PINK CRYSTALS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:STABLE UNDER ORDINARY CONDITIONS OF USE &
STORAGE. ADDITION OF ACID TO AQUEOUS SOLUTION PRDCES WHITE
TURBIDITY (SUPDAT)
Hazardous Decomposition Products:WHEN HEATED TO DECOMPOSITION, IT EMITS
FUMES OXIDES OF NITROGEN AND SULFUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:WHATEVER CANNOT BE SAVED FOR RECLAMATION MAY BE
DISPOSED IN A RCRA APPROVED HAZARDOUS WASTE FACILITY. ENSURE
COMPLIANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:177 7846,EKTAPRINT 3 DEVELOPER,PART C
CAGE:19139
CAGE:19139
============= Composition/Information on Ingredients =============
Ingred Name:4-AMINO-N-ETHYL-N-(B-METHANESULFONAMIDOETHYL)-M-TOLUIDINE
SESQUISULFATE MONOHDRATE(20-25%
Fraction by Wt: 22.5%
ACGIH TLV:5 PPM(AS SO*2)
Ingred Name:AQUEOUS SOLUTION,HAZARD UNKNOWN,UNIDENTIFIED
Fraction by Wt: 77.5%
===================== Hazards Identification =====================
Effects of Overexposure:INH:SO*2 CAUSES IRRIT;EYES:SO*2/LIQ CAUSES
IRRIT;SKIN:LIQ CONTCT CAUSES IRRIT.MAY CAUSE ALLERGY ACTN
======================= First Aid Measures =======================
First Aid:INH:REMOVE FROM EXPOSURE.GIVE CPR/OXY IF NEEDED & GET MED
ATTN;EYES:FLUSH IMMED W/WATER FOR AT LEAST 15 MIN.GET MED
HELP;SKIN:FLUSH IMMED W/PLENTY OF WATER FOR 15 MIN.FOR IRRIT GET
MED ATTN.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:CO*2,DRY CHEM
Fire Fighting Procedures:USE SELF-CONTND BRTHG APP;COOL EXPSD CONT
W/WATER SPRAY.
Unusual Fire/Explosion Hazard:NONE KNOWN
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE UNPROTECTED PERSONS,PROVIDE
VENTILATION/SAFETY EQUIPMENTS IF NECESSARY.DIKE LG SPILL & PUMP
INTO COVERED CONTNRS;ABSORB SM SPILL W/ABSORBING MATL & PLACE IN
SAME CONTNR;MFR SUGGESTS FLUSH DOW N TO SEWER W/LG AMT OF H*2O IAW
EXISTING REGS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY,WELL VENTILATED
AREA.KEEP CONTNRS TIGHTLY CLOSED.PROTECT CONTNRS FROM PHYSICAL
DAMAGE.
Other Precautions:AVOID PROLONGED/REPEATED CONTACT W/PRODUCT.ROUTINE
USE OF A NON-ALKALINE(ACID)TYPE HAND CLEANER WILL HELP MINIMIZE OF
ALLERGIC SKIN REACTION;APPROX PRODUCT PH:1.0.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQD IN NORMAL CONDITIONS
Ventilation:MECHANICAL(GEN) IF NEEDED
Other Protective Equipment:AS NECESSARY TO PREVENT SKIN CONTACT.
Supplemental Safety and Health
MSDS FM MFR DATE:10-21-75;PER MFR,ITEM DISCONTD APPROX 1979;THIS DATA
FOR PART C OF 3 PART PRODUCT;PROD DISSOCIATES TO H*2SO*4 IN SOLN,C2
STORAGE CODE ASSIGNED;UNIT CONTN QTY YIELDS 1 QT SOLN.
================== Physical/Chemical Properties ==================
HCC:C1
Boiling Pt:B.P. Text:>212F/>100C
Vapor Pres:17
Vapor Density:0.6
Spec Gravity:1.19
Solubility in Water:COMPLETE
Appearance and Odor:PUNGENT SULFUR DIOXIDE ODOR,AMBER COLOR LIQ.
Percent Volatiles by Volume:65%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
PER MFR AVOID FROM MINERAL ACIDS & STRONG ALKALI
Hazardous Decomposition Products:SULFUR DIOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:KEEP IN COVERED CONTAINERS PENDING
DISPOSAL.DISPOSE IN FULL COMPLIANCE W/FEDERAL,STATE & LOCAL
REGULATIONS;MFR RECOMMENDS TO FLUSH DOWN TO SEWER W COPIOUS AMT
H*2O.STATE & LOCAL EFFLUENT LAWS TAKE PRE CEDENCE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:A-1192-154/GRAY
Kit Part:Y
CAGE:GO941
CAGE:80592
CAGE:GO941
============= Composition/Information on Ingredients =============
Ingred Name:N-BUTYL ALCOHOL
ACGIH TLV:50 PPM
Ingred Name:POLYAMIDE
===================== Hazards Identification =====================
Effects of Overexposure:EYE,THROAT,SKIN,LUNG IRRITANT
======================= First Aid Measures =======================
First Aid:WASH SKIN THOROUGHLY, FLUSH EYES WITH WATER, REMOVE TO FRESH
AIR, REMOVE CONTAMINATED CLOTHING, GIVE ARTIFICIAL RESPIRATION IF
NEEDED, CALL DOCTOR, DO NOT INDUCE VOMITING.
===================== Fire Fighting Measures =====================
Flash Point:99F,37.2 C CC
Extinguishing Media:FOAM,DRY CHEMICAL,FOG,CO2,WATER SPRAY
Unusual Fire/Explosion Hazard:AVOID FIRE, HEAT, SPARKS, IGNITION
SOURCES,DIRECT SUNLIGHT
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA, KEEP FROM FLAME, FIRE, SPARKS,
IGNITION SOURCES. DO NOT BREATHE VAPORS; MECHANICALLY VENTILATE;
CLEAN UP WITH ABSORBENT MATERIAL
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS CLOSED, UPRIGHT, AWAY
FROM FIRE, FLAME, SPARKS, IGNITION SOURCES,DIRECT SUNLIGHT
Other Precautions:DO NOT USE IN CONFINED AREAS
============= Exposure Controls/Personal Protection =============
Ventilation:LOCAL EXHAUST
Supplemental Safety and Health
2 COMPONENT SYSTEM FORMULA 154, COMPOSITION A.KEY1:F4.
================== Physical/Chemical Properties ==================
HCC:F4
Vapor Density:>AIR
Spec Gravity:10.1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:GRAY VISCOUS LIQUID
Percent Volatiles by Volume:58.0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:DP401LF EPOXY PRIMER CATALYST
CAGE:DO542
CAGE:DO542
============= Composition/Information on Ingredients =============
Ingred Name:ISOPROPANOL (ISOPROPYL ALCOHOL), 2-PROPANOL, DIMETHYL
CARBINOL(IARC CANCER REVIEW GROUP 3) *96-2*
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 5-10%
Other REC Limits:400 PPM
OSHA PEL:400 PPM
ACGIH TLV:400 PPM
Ingred Name:ACETIC ACID, C6-8-BRANCHED ALKYL ESTERS, C3-8-BRANCHED
ALKYL ESTERS ACETIC ACID
CAS:90438-79-2
Fraction by Wt: 15-20%
Ingred Name:XYLENE, DIMETHYLBENZENE, XYLOL (IARC - GROUP 3) *96-2*
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 15-20%
Other REC Limits:100 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM, SKIN
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:FILM FORMERS, RESINS, AND ADDITIVES
Fraction by Wt: 25-30%
Ingred Name:GLYCOL ETHERS
Fraction by Wt: 5-10%
Ingred Name:2-HEPTANONE, METHYL N-AMYL KETONE
CAS:110-43-0
RTECS #:MJ5075000
Fraction by Wt: 20-25%
Other REC Limits:50 PPM
OSHA PEL:465 MG/CUM
ACGIH TLV:233 MG/CUM
Ingred Name:2-BUTOXYETHANOL (ETHYLENE GLYCOL MONOBUTYL ETHER), BUTYL
CELLOSOLVE, BUTYL GLYCOL, GLYCOL ETHER EB * 96-2 *
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: 5-10%
Other REC Limits:25 PPM (SKIN)
OSHA PEL:50 PPM (SKIN)
ACGIH TLV:25 PPM (SKIN)
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:HARMFUL IF SWALLOWED/INHALED. MAY BE
ABSORBED THROUGH THE SKIN. EYES: IRRITATION. SKIN: IRRITATION.
INHALATION: IRRITATION TO EYES, NOSE & THROAT. REPEATED EXPOSURE TO
HIGH VAPOR CONCENTRATIONS MAY CA USE IRRITATION OF THE RESPIRATORY
SYSTEM & PERMANENT BRAIN & NERVOUS SYSTEM DAMAGE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, EYE WATERING, HEADACHES, NAUSEA,
DIZZINESS, LOSS OF COORDINATION, REDNESS, ITCHING, BURNING, VISUAL
DISTURBANCES, DRYNESS, CRACKING, SWELLING.
======================= First Aid Measures =======================
First Aid:INGESTION: DON'T INDUCE VOMITING. EYES: FLUSH W/WATER FOR 15
MINS. SKIN: FLUSH W/WATER, FOLLOWED BY WATERLESS HAND CLEANER &
SOAP. INHALATION: REMOVE TO FRESH AIR. GIVE CPR IF NEEDED. OBTAIN
MEDICAL A TTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:40F
Lower Limits:1.5
Extinguishing Media:CO2, DRY CHEMICAL/UNIVERSAL AQUEOUS FILM FORMING
FOAM.
Fire Fighting Procedures:WATER SPRAY MAY BE INEFFECTIVE. WATER SPRAY
MAY BE USED TO COOL CLOSED CONTAINERS. IF WATER IS USED, FOG
NOZZLES ARE PREFERABLE. WEAR SCBA.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE
FROM HEAT, ELECTRICAL EQUIPMENT & OTHER IGNITION SOURCES. DON'T
APPLY TO HOT SURFACES. (SEE SUPP)
================== Accidental Release Measures ==================
Spill Release Procedures:USE MAXIMUM VENTILATION. ONLY PERSONNEL
REMOVE IGNITION SOURCES. TAKE UP W/SAWDUST, VERMICULITE/OTHER
ABSORBENT MATERIAL & PLACE INTO CO NTAINERS FOR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:GROUND CONTAINER WHEN POURING. AVOID
FREE FALL OF LIQUIDS IN EXCESS OF A FEW INCHES. DON'T STORE >120F.
Other Precautions:INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING &
INHALING THE CONTENTS CAN BE HARMFUL/FATAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED AIR PURIFYING/AIR
SUPPLIED RESPIRATORS.
Ventilation:GENERAL DILUTION/LOCAL EXHAUST VENTILATION.
Other Protective Equipment:IMPERMEABLE APRON
Supplemental Safety and Health
UNUSUAL FIRE CONT'D: CLOSED CONTAINERS MAY EXPLODE WHEN EXPOSED TO
EXTREME HEAT. TOXIC GASES MAY FORM WHEN PRODUCT IS CONTACTED BY
FLAME/HOT SURFACES.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:179.6-392F
Vapor Pres:7.8
Vapor Density:>1
Spec Gravity:0.88
Evaporation Rate & Reference:(BU OAC =100): 59
Solubility in Water:15.3
Appearance and Odor:VISCOUS LIQUID W/CHARACTERISTIC ODOR OF THE
SOLVENTS LISTED.
Percent Volatiles by Volume:73
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ALKALIES, STRONG MINERAL ACIDS/STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAMES, ELECTRICAL
EQUIPMENT & OTHER IGNITION SOURCES. TEMP >120F.
Hazardous Decomposition Products:HEATED, WELDING, BRAZING/FLAME
CUTTING: CO, OXIDES OF NITROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS. EMPTY CONTAINERS SHOULD BE RECYCLED/DISPOSED OF
THROUGH AN APPROVED WASTE MANAGEMENT FACILITY.
| 1 | gloves_mandatory |
=======================================================
NIIN: 00-774-5767
Product ID: LAUNDRY TARGO
Cage: 98443
Box: 207
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 98443
Box: 207
=======================================================
Item Description Information
=======================================================
Item Manager: S9G
Item Name: SPOT REMOVER
Specification Number: NONE
Type/Grade/Class: NONE
Unit of Issue: GL
UI Container Qty: 0
Type of Container: BOTTLE
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: LD50 (ORAL, RAT) IS NOT KNOWN.
Route Of Entry Inds - Inhalation: NO
Skin: NO
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: TARGET ORGANS:EYES, SKIN, RESPIRATORY AND GASTROINTESTINAL
TRACTS. ACUTE- EYES:CAN IRRITATE. SKIN:CAN IRRITAATE AND DEFAT.
INHALATION:OVEREPOSURE MAY CAUSE IRRITATION OR DRYNESS OF NOSE AND THROAT. IN
GESTION:MAY CAUSE COUGHING AND VOMITING. CHRONIC- UNKNOWN
Explanation Of Carcinogenicity: NONE
Signs And Symptions Of Overexposure: IRRITATION, COUGHING, DEFATTING AND DRYING
OF SKIN, NAUSEA, VOMITING
Medical Cond Aggravated By Exposure: PERSONS WITH PRE-EXISTING SKIN DISORDERS,
EYE PROBLEMS OR IMPAIRED RESPIRATORY FUNCTION MAY BE MORE SUSCEPTIBLE TO THE
EFFECTS OF THIS PRODUCT.
First Aid: GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALED:REMOVE TO FRESH AIR.
PROVIDE CPR/OXYGEN IF NEEDED. EYES:FLUSH WITH WATER FOR 15 MINUTES, HOLDING
EYELIDS OPEN. SKIN:WASH WITH SOAP & WATER. ORAL:GET MEDIC AL ATTENTION AS
SOON AS POSSIBLE.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: PREVENT SKIN AND EYE CONTACT. ABSORB SPILLS WITH
INERT MATERIAL SUCH AS SAND OR VERMICULITE. SCRAPE SPILL UP INTO NONPOROUS
CONTAINERS. CLEAN SPILL AREA WITH SOAP AND WATER.
Neutralizing Agent: NOT RELEVANT
Waste Disposal Methods: DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE AND
FEDERAL REGULATIONS.
Handling And Storage Precautions: STORE IN COOL AND VENTILATED PLACE.
Other Precautions: WASH THOROUGHLY WITH SOAP AND WATER AFTER HANDLING AND
BEFORE EATING, DRINKING, SMOKING. KEEP OUT OF REACH OF CHILDREN.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: PMCC
Flash Point Text: >214F,>101C
Lower Limits: UNKNOWN
Upper Limits: UNKNOWN
Extinguishing Media: WATER, CARBON DIOXIDE, SAND, FOAM/DRY CHEMICAL. WATER
SPRAY MAY BE USED TO KEEP FIRE EXPOSED CONTAINERS COOL.
Fire Fighting Procedures: WEAR PROTECTIVE CLOTHING AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard: UNKNOWN
=======================================================
Control Measures
=======================================================
Respiratory Protection: NONE REQUIRED WHEN USED WITH ADEQUATE VENTILATION.
Ventilation: ADEQUATE
Other Protective Equipment: EYE WASH STATION, SAFETY SHOWER, PROTECTIVE
CLOTHING
Work Hygienic Practices: OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES.
Supplemental Safety and Health: FORMULA CHANGED. FOR PREVIOUS FORMULATIONS, SEE
PNI A AND B, SAME NSN.
=======================================================
Physical/Chemical Properties
=======================================================
HCC: N1
NRC/State LIC No: NOT RELEVANT
B.P. Text: 210F,99C
M.P/F.P Text: <22F,<-6C
Decomp Text: UNKNOWN
Vapor Pres: UNKNOWN
Vapor Density: UNKNOWN
Spec Gravity: 1.0
Viscosity: UNKNOWN
Evaporation Rate & Reference: UNKNOWN
Solubility in Water: HIGHLY SOLUBLE
Appearance and Odor: CLEAR TO YELLOW LIQUID, WITH LIGHT CITRUS ODOR
Corrosion Rate: UNKNOWN
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: OPEN FLAME AND EXTREME HEAT
Materials To Avoid: UNKNOWN
Hazardous Decomposition Products: MAY FORM CARBON MONOXIDE, CARBON DIOXIDE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
Transportation Information
=======================================================
Trans ID NO: 85067
Product ID: LAUNDRY TARGO
Review Date: 10/25/1995
Net Unit Weight: 8.3 LBS
Multiple KIT Number: 0
Review IND: Y
Unit Of Issue: GL
Container QTY: 0
Type Of Container: BOTTLE
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: ZZZ
DOT Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: ZZZ
IMO Proper Shipping Name: NOT REGULATED FOR THIS MODE OF TRANSPORTATION
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: ZZZ
IATA Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: ZZZ
AFI Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
HAZCOM Label
=======================================================
Product ID: LAUNDRY TARGO
Cage: 98443
Company Name: WILSON A L CHEMICAL CO
Street: 1050 HARRISON AVE.
PO Box: 207
Zipcode: 07032
Label Required IND: Y
Date Of Label Review: 10/25/1995
Status Code: C
MFG Label NO: NOT RELEVANT
Label Date: 10/25/1995
Origination Code: F
Skin Protection IND: YES
Signal Word: CAUTION
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: TARGET ORGANS:EYES, SKIN, RESPIRATORY & GI TRACTS.
ACUTE- EYES:CAN IRRITATE. SKIN:CAN IRRITAATE & DEFAT. INHALE:OVEREPOSURE
MAY CAUSE IRRITATION/DRYNESS OF NOSE & THROAT. ORAL:MAY CAUSE COUGH &
VOMITI NG. CHRONIC- UNKNOWN. STORE IN COOL & VENTILATED PLACE. ABSORB
SPILLS WITH INERT MATERIAL SUCH AS SAND OR VERMICULITE. SCRAPE SPILL UP INTO
NONPOROUS CONTAINERS. CLEAN SPILL AREA WITH SOAP AND WATER. FIRST AID- GET
MEDICAL HELP IF SYMPTOMS PERSIST. INHALED:REMOVE TO FRESH AIR. PROVIDE
CPR/OXYGEN IF NEEDED. EYES:FLUSH WITH WATER FOR 15 MINUTES, HOLDING EYELIDS
OPEN. SKIN:WASH WITH SOAP & WATER. ORA L:GET MEDICAL ATTENTION AS SOON AS
POSSIBLE.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:BERYLLIUM METAL AND POWDER
CAGE:4B151
CAGE:97153
CAGE:4B151
============= Composition/Information on Ingredients =============
Ingred Name:BERYLLIUM (SARA III)
CAS:7440-41-7
RTECS #:DS1750000
OSHA PEL:2 UG/M3
ACGIH TLV:0.002PPM; A2; 9293
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHAL:MAY CAUSE BERYLLIOSIS, A SERIOUS
CHRONIC LUNG DISEASE, WITH COUGH, CHEST PAIN, SHORTNESS OR BREATH,
WEIGHT LOSS, WEAKNESS, AND FATIGUE. SKIN:NO ACUTE HAZ. HANDLING OF
SOLID SHAPES PRESENTS NO DE RMAT OR SKIN ABSORPTION PROBLEM.
DERMATFROMHANDLING POWDER IS LIMITED TO THE PHYSICAL NATURE OF
POWDER (SEE OVEREXPO)
Explanation of Carcinogenicity:CLASS 2A (IARC), CLASS 2, (NTP)
Effects of Overexposure:HLTH HAZ: (ABRASION), NOT THE CHEMICAL NATURE.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE FROM EXPOSURE AND CONSULT A PHYSICIAN.
INGEST:GET MD IMMEDIATELY . EYES:FLUSH FOR AT LEAST 15 MIN .
===================== Fire Fighting Measures =====================
Extinguishing Media:SMOTHER POWDER FIRES WITH DRY SAND, GRAPHITE POWDER
OR SODIUM CHLORIDE. DO NOT USE WATER OR CARBON DIOXIDE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT TO PROTECT AGAINST AIRBORNE BERYLLIUM.
Unusual Fire/Explosion Hazard:BERYLLIUM POWDER WILL IGNITE AT
APPROXIMATELY 1200F. THE POWDER IS NOT EXPLOSIVE.
================== Accidental Release Measures ==================
Spill Release Procedures:IMMED EVACUATE & PHYSICALLY ISOLATE THE AREA.
ONLY PERSONNEL EQUIPPED W/PROPER RESPIRATORS AND PROTECTIVE
CLOTHING SHALL BE PERMITTED IN AREA. CLEAN UP POWDER SPILLS
PROMPTLY BY VACUUM AND WET CLEANIN G METHODS TO AVOID GENERATING
DUST.(SEESUPP DATA)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED SCBA AND HIGH EFFICIENCY
CARTRIDGE ARE REQUIRED IF BERYLLIUM IN AIR CONCENTRATIONS EXCEED
OSHA STANDARD.
Ventilation:LOCAL EXHAUST WHEN PERFORMING OPERATIONS SUCH AS MELTING,
CRUSHING, MACHINING, GRINDING, WELDING, ETC.
Other Protective Equipment:FULL BODY PROT CLTHG. ALL CONTAM CLTHG
SHOULD BE PLACED IN SEALED CONTAINERS AND SENT TO SPECIAL LAUNDRY
FACILITIES.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
SPILL PROC:VACUUM EQUIPMENT SUPPLIED WITH HEPA FILTERS MUST BE USED.
WASTE DISP METH:PLASTIC BAGS AND PLACED WITHIN A DOT CONTAINER
APPROVED FOR POISON B COMPOUNDS. THE OUTER CONTAINER MUST BE
LABELED WITH THE APPROPRIATE EPA AND DOT HAZARD WARNING LABELS AND
SHIPPED TO AN APPROVED HAZARDOUS WASTE DISPOSAL SITE.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:5378F,2970C
Melt/Freeze Pt:M.P/F.P Text:2332F,1278C
Spec Gravity:1.85 @ 20C
Appearance and Odor:GRAY METALLIC SOLID OR POWDER, NO ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:BERYLLIUM METAL SCRAP, CHIPS AND POWDER ARE
NORMALLY RECYCLED. IN CASES WHERE THIS IS NOT JUSTIFIED: 1. SOLID
MATL MAY BE LANDFILLED. 2. METAL DUST OR POWDER, INCLUDING THAT
CONTAINED IN DUST COLLECTO R FILTERS, MUST BE SEALED IN TWO (SEE
SUPP DATA)
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PHOTAFIX 224 FIXER/REPLENISHER, 28031
CAGE:1CG79
CAGE:1CG79
============= Composition/Information on Ingredients =============
Ingred Name:THIOSULFURIC ACID, DIAMMONIUM SALT; (AMMONIUM THIOSULFATE)
CAS:7783-18-8
RTECS #:XN6465000
Fraction by Wt: 15-20%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SODIUM SULFITE
CAS:7757-83-7
RTECS #:WE2150000
Fraction by Wt: 1-5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ACETIC ACID (CERCLA)
CAS:64-19-7
RTECS #:AF1225000
Fraction by Wt: 1-5%
OSHA PEL:10 PPM
ACGIH TLV:10 PPM/15 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 55-60%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION: LOW HAZARD FOR
ORDINARY INDUSTRIAL HANDLING. EYES: CONTACT MAY CAUSE IRRITATION.
SKIN: REPEATED AND PROLONGED CONTACT MAY CAUSE IRRITATION.
INGESTION: DO NOT TAKE INTERNALLY. MAY BE HARMFUL IF SWALLOWED.
CHRONIC: NONE SPECIFIED BY MANUFACTURER.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH LARGE AMOUNTS OF WATER FOR AT LEAST 15
MINUTES. SEEK MEDICAL ATTENTION. SKIN: WASH WITH SOAP AND WATER. IF
IRRITATION OCCURS, SEEK MEDICAL ATTENTION. INGESTION: INDUCE
VOMITING. SEEK MEDICAL ATTENTION IMMEDIATELY GIVING FULL DETAILS
OF AMOUNT INGESTED AND TOXICITY. INHALATION: MOVE TO FRESH AIR.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:USE METHOD APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:WHEN HEATED TO DECOMPOSITION, IT CAN EMIT
TOXIC FUMES OF SO*X AND AMMONIA.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE CLOTHING AS SPECIFIED.
NEUTRALIZE WITH SODIUM BICARBONATE. IF FEDERAL, STATE AND LOCAL
LAWS PERMIT, FLUSH TO SEWER WITH LARGE AMOUNTS OF WATER.
Neutralizing Agent:SODIUM BICARBONATE.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE OR CONSUME FOOD, DRINK OR
TOBACCO IN SURROUNDING AREA.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SHOULD NOT BE NECESSARY UNDER NORMAL CONDITIONS.
IF EXPOSED TO VAPORS THAT EXCEED TLV OR PEL, WEAR A NIOSH APPROVED
VAPOR RESPIRATOR.
Ventilation:GOOD LOCAL MECHANICAL VENTILATION SHOULD BE SUFFICIENT.
Other Protective Equipment:ANSI APPROVED EMERGENCY EYEWASH AND DELUGE
SHOWER . WEAR PROTECTIVE CLOTHING AS NECESSARY TO PREVENT SKIN
CONTACT.
Work Hygienic Practices:WASH THOROUGHLY AFTER USE.
Supplemental Safety and Health
WASTE DISP METH: AGENCIES TO ASCERTAIN PROPER DISP PROCEDURES.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>212F,>100C
Vapor Pres:17.0
Vapor Density:0.6
Spec Gravity:1.33
pH:4.6
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, SLIGHT VINEGAR ODOR
Percent Volatiles by Volume:65(WT)
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MINERAL ACIDS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:WHEN HEATED TO DECOMPOSITION, IT CAN
EMIT TOXIC FUMES OF SO*2, CARBON DIOXIDE AND POSSIBLY CARBON
MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:NEUT W/SODIUM BICARBONATE. IF FED, STATE &/LOC
LAWS PERMIT, FLUSH TO SEWER W/LGE AMTS OF WATER. OTHERWISE DISP OF
CONTAM PROD & MATLS USED IN CLEANING UP SPILL IN A MANNER APPRVD
FOR THIS MATL. CONSUL T PROPER FED, STATE &/LOC REGULATORY (SUP
DAT)
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:EATHLIGHT SLS23
CAGE:62607
CAGE:62607
============= Composition/Information on Ingredients =============
Ingred Name:PHOSPHOR POWDER (INCLUDES INGRED #2)
Fraction by Wt: <0.5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:YTTRIUM OXIDE (AS YTTRIUM)
CAS:1314-36-9
RTECS #:ZG3850000
Fraction by Wt: <0.5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:LEAD (SARA 313) (CERCLA)
CAS:7439-92-1
RTECS #:OF7525000
Fraction by Wt: <0.05%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:SEE 1910.1025
ACGIH TLV:0.15MG/M3 DUST; 9495
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:TIN
CAS:7440-31-5
RTECS #:XP7320000
Fraction by Wt: <0.1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3; 9495
Ingred Name:BISMUTH
CAS:7440-69-9
RTECS #:EB2600000
Fraction by Wt: <0.005%
Other REC Limits:NONE RECOMMENDED
Ingred Name:MERCURY (SARA 313) (CERCLA)
CAS:7439-97-6
RTECS #:OV4550000
Fraction by Wt: 0.005%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:C, 0.1 MG/M3; Z-2
ACGIH TLV:S,0.025 MG/M3; A4;95
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:GLASS (LMAP ENVEOLPE)
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Health Hazards Acute and Chronic:N/A TO INTACT LAMP.LUMINESCENT MATLS
CONTAINED WITHIN GLASS TUBES.BREAKAGE OF TUBE MAY RESULT IN SOME
EXPO TO PHOSPHOR POWDER DUST,MERCURY,SMALL ATMS OF
TIN,LEAD,BISMUTH.NO ADVERSE AFFECTS ARE EXPECTE D FRM OCCASSIONAL
EXPO TO BROKEN LAMPS BUT AS MATTER OF GOOD PRACTICE
PROLONGED/FREQUENT EXPO SHOULD BE AVOIDED (SUPPLE)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:NORMAL FIRST AIR PROCEDURE FOR GLASS CUTS IF SUCH OCCUR
THROUGH LAMP BREAKAGE.
===================== Fire Fighting Measures =====================
Flash Point:NOT FLAMMABLE
Unusual Fire/Explosion Hazard:UNDER EXTREME HEAT GLASS TUBE MIGHT MELT
OR CRACK.
================== Accidental Release Measures ==================
Spill Release Procedures:NORMAL PRECAUTIONS SHOULD BE TAKEN FOR
COLLECTION OF BROKEN GLASS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:FOR INDOOR/OUTDOOR USE WHERE NOT SUBJ
TO WEATHER.NOT FOR USE IN LIGHTING DEVICES CNTRLD BY
DIMMERS.RELIABLE OPERATION DOWN TO 0F(WINDCHILL NOT FACTOR)
Other Precautions:CUSTOMERS SHOULD REVIEW THEIR WASTE HANDLING
PRACTICES TO ASSRUE THAT THEY ARE PROPERLY DISPOSING OF WASTE
LAMPS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:APPROPRIATE DUST MASK SHOULD BE USED IF LARGE
VOLUMES OF LAMPS ARE BEING BROKEN FOR DISPOSAL.
Ventilation:AVOID INHALATION OF ANY AIRBORNE DUST.PROVIDE LOCAL EXHAUST
WHEN DISPOSING LARGE QUANTITIES OF LAMPS.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:AS MATTER OF GOOD PRACTICE PROLONGED/FREQUENT
EXPO SHOULD BE AVOIDED THRU USE OF ADEQUATE VENTI DURING DISPO OF
LG AMTS.
Supplemental Safety and Health
HEALTH HAZ:THRU ADEQ VENTI DURING LG QUANT OF LAMP DISPO. DISPO:LAMPS
FRM ALL MFG EXHIBIT SAME PHENOMENA.NEMA WORKS CLOSELY W/EPA FOR
CLARIF/GUIDANCE.SM AMT PLACED IN ORDINARY TRASH NOT APPREC AFFECT
METHOD OF DISPO.SPENT LAMPS ADD TO OTHER REG WASTE/LG AMTS,DISPO
REG.
================== Physical/Chemical Properties ==================
HCC:N1
Appearance and Odor:ARITCLE, ITEM IS A LIGHT BULB.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
THE GLASS WILL REACT WITH HYDROFLUORIC ACID.
==================== Disposal Considerations ====================
Waste Disposal Methods:UNDER TCLP PROMULGATED BY US EPA,TESTS OF
USED/SPECNT FLUORESCENT/INCANDESCENT/HIGH INTENSITY DISCHARGE LAMPS
INDICATE SOME TYP MAY BE CLASSIFIED AS CHARACTERI HAZ WASTE.NOTABLY
TCLP RESULTS FOR FLUOR ESCENT LAMPS VARY TREMENDOUSLY FRM LAB TO
LAB(SUP)
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:DISHWASHING COMPOUND (CHLORINATED)
Preparer's Name:I. HADJILOUKAS
CAGE:74381
CAGE:74381
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM HYDROXIDE (SARA III)
CAS:1310-73-2
RTECS #:WB4900000
Fraction by Wt: 15%
Other REC Limits:NONE SPECIFIED
OSHA PEL:2 MG/M3
ACGIH TLV:C 2 MG/M3; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SODIUM METASILICATE
CAS:6834-92-0
RTECS #:VV9275000
Fraction by Wt: 10%
Other REC Limits:NONE SPECIFIED
ACGIH TLV:2 MG/M3
Ingred Name:SODIUM DICHLOROISOCYANURATE DIHYDRATE
CAS:7647-14-5
Fraction by Wt: 2%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: CAUSES SEVERE DAMAGE AND MAY
EVEN RESULT IN BLINDNESS. SKIN: CAUSES SEVERE BURNS. INGESTION:
CAUSES SEVERE DAMAGE TO MUCOUS MEMBRANE.
Effects of Overexposure:EYES: IRRITATION, REDNESS. SKIN: DRYNESS, RED
IRRITATION. INHALATION: IRRITATION TO MUCOUS MEMBRANE.
Medical Cond Aggravated by Exposure:RESPIRATORY
======================= First Aid Measures =======================
First Aid:SKIN, EYES: FLUSH FOR AT LEAST 15 MINUTES WITH WATER. CONTACT
A PHYSICIAN. INGESTION: DO NOT INDUCE VOMITING. GIVE WATER AND MILK
OF MAGNESIA. CONTACT A PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:NA
================== Accidental Release Measures ==================
Spill Release Procedures:COLLECT MATERIAL INTO PAPER. DISSOLVE IN WATER
AND NEUTRALIZE BEFORE DISPOSAL TO SEWER.
Neutralizing Agent:WEAK ACIDS
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN DRY PLACE. KEEP CONTAINER
TIGHTLY CLOSED AND AWAY FROM FOODS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH RESPIRATOR FOR DUSTS.
Ventilation:MECHANICAL
Other Protective Equipment:RUBBER APRON AND BOOTS
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:B1
Decomp Temp:Decomp Text:482F,250C
Spec Gravity:0.85
pH:13.5
Solubility in Water:APPRECIABLE
Appearance and Odor:WHITE GRANULAR POWDER WITH CHARACTERISTIC CHLORINE
SMELL.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ORGANIC MATERIALS AND STRONG ACIDS MAY RESULT IN EMISSION OF CHLORINE
GAS.
Stability Condition to Avoid:STRONG ACIDS, REACTIVE METALS SUCH AS
ALUMINUM OR MAGNESIUM.
Hazardous Decomposition Products:CHLORINE GAS
==================== Disposal Considerations ====================
Waste Disposal Methods:IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
REGULATORY AGENCY.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TT-E-529G GREEN #24260
Preparer's Name:ONEY FLEMING
CAGE:JO954
CAGE:JO954
CAGE:39934
============= Composition/Information on Ingredients =============
Ingred Name:MEDIUM ALIPHATIC SOLVENT NAPHTHA
CAS:64742-88-7
Fraction by Wt: 32.0%
Other REC Limits:NONE RECOMMENDED
Ingred Name:NON-HAZARDOUS INGREDIENTS
Fraction by Wt: 68.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT RELEVANT
ACGIH TLV:NOT RELEVANT
Ingred Name:VOC = 2.91 LBS/GL
RTECS #:9999999VO
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT RELEVANT
ACGIH TLV:NOT RELEVANT
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: REDNESS, PAIN. SKIN: REDNESS.
INHAL: LABORED BREATHING, DULLNESS, DROWSINESS. INGEST: ABDOMINAL
PAIN, NAUSEA. CHRONIC: EYE: IRRITATION, REDNESS, TEARING, BLURRED
VISION. SKIN: IRRITATION, DEFATTI NG, DERMATITIS. INHAL:
NASAL/RESPIRATORY IRRIT, DIZZINESS, NAUSEA, HEADACHE. INGEST: GI
IRRITATION, NAUSEA, VOMITING.
Medical Cond Aggravated by Exposure:RESPIRATORY SYSTEM DISEASES.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH W/LARGE AMOUNTS OF WATER FOR 15 MINUTES, LIFT
LIDS, GET MED AID. SKIN: REMOVE CONTAM CLOTHES, WASH BEFORE REUSE.
WASH SKIN W/SOAP & WATER. INHAL: REMOVE TO FRESH AIR. GIVE OXYGEN
IF NEEDED.GET MED AID. INGEST: KEEP WARM/QUIET. GET MED AID. DONT
INDUCE VOMIT.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:100F,38C
Autoignition Temp:Autoignition Temp Text:540F
Lower Limits:1.0
Upper Limits:6.0
Extinguishing Media:CO2, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:USE SCBA & FULL PROTECTIVE GEAR. USE WATER
SPRAY TO COOL CONTAINERS. (PREVENT PRESSURE
BUILDUP/AUTOIGNITION/EXPLOSION).
Unusual Fire/Explosion Hazard:WATER MAY SPREAD FIRE. VAPORS >AIR, MAY
TRAVEL TO IGNITION SOURCE & FLASH BACK.
================== Accidental Release Measures ==================
Spill Release Procedures:VENT AREA. COVER W/INERT ABSORBENT. SHOVEL
W/NONSPARKING TOOLS INTO CONTAINER. REMOVE TO SAFE AREA & SEAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN CLEAN, DRY AREA. KEEP AWAY
FROM IGNITION SOURCES.
Other Precautions:KEEP CONTAINER TIGHTLY CLOSED. KEEP AWAY FROM
CHILDREN. GROUND EQUIPMENT TO REDUCE STATIC ELECTRICITY HAZARD. USE
NONSPARKING TOOLS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE A RESPIRATOR W/APPROPRIATE CARTRIDGES (NIOSH
APPROVED).
Ventilation:LOCAL EXHAUST.
Other Protective Equipment:EYEWASH STATION, SAFETY SHOWER & IMPERVIOUS
CLOTHING.
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:305 TO 396F
Melt/Freeze Pt:M.P/F.P Text:NA
Decomp Temp:Decomp Text:752F,400C
Vapor Pres:2.58
Vapor Density:>AIR
Spec Gravity:1.09
pH:NA
Viscosity:65-72 KU
Evaporation Rate & Reference:<ETHER
Solubility in Water:NO
Appearance and Odor:LIQUID, W/SLIGHT ODOR.
Percent Volatiles by Volume:49.2
Corrosion Rate:NA
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:IGNITION SOURCES.
Hazardous Decomposition Products:CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:IN ACCORDANCE W/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:DEXTROSE INJECTION
Preparer's Name:GREGORY KOLAR
CAGE:24832
CAGE:24832
CAGE:39832
CAGE:0K706
============= Composition/Information on Ingredients =============
Ingred Name:DEXTROSE
CAS:50-99-7
Other REC Limits:NONE RECOMMENDED
Ingred Name:WATER FOR INJECTION (NOTE: PRESERVATIVE FREE)
CAS:7732-18-5
RTECS #:ZC0110000
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT) IS 25800 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE, SKIN AND RESPIRATORY IRRITATION
MAY OCCUR. THIS PRODUCT IS INTENDED FOR THERAPUTIC USE ONLY WHEN
PRESCRIBED BY A PHYSICIAN. POTENTIAL ADVERSE REACTIONS FROM
PRESCRIBED DOSES AND OVERDOSES ARE DES CRIBED IN PACKAGE INSERT.
OCCUPATIONAL EXPOSURE HAS NOT BEEN FULLY INVESTIGATED.
Effects of Overexposure:EYE, SKIN AND RESPIRATORY IRRITATION MAY OCCUR.
THIS PRODUCT IS INTENDED FOR THERAPUTIC USE ONLY WHEN PRESCRIBED BY
A PHYSICIAN. POTENTIAL ADVERSE REACTIONS FROM PRESCRIBED DOSES AND
OVERDOSES ARE DES CRIBED IN PACKAGE INSERT. OCCUPATIONAL EXPOSURE
HAS NOT BEEN FULLY INVESTIGATED.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH LARGE AMOUNTS OF WATER. GET MEDICAL
ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING. FLUSH AREA WITH
LARGE AMOUNTS OF WATER. GET MEDICAL ATTENTION. INHALATION: MOVE TO
FRESH AIR. IF NOT BREATHING GIVE CPR. GET MEDICAL ATTENTION.
INGESTION: FLUSH MOUTH OUT WITH WATER IMMEDIATELY. GET MEDICAL
ATTENTION. GENERAL: FOR ADDITIONAL INFORMATION SEE THE PRODUCT
INSERT.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:>200F,>93C
Extinguishing Media:WATER SPRAY, DRY CHEMICAL, CARBON DIOXIDE OR FOAM
AS APPROPRIATE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN-UP: WEAR RECOMMENDED PERSONAL PROTECTIVE
EQUIPMENT. USE ABSORBENT TOWELS OR BOOMS TO CLEAN-UP SPILL. WIPE
SURFACES CLEAN AND WASH WITH SOAP AND WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AS A GENERAL RULE, WHEN HANDLING
PHARMACEUTICAL PRODUCTS AVOID ALL CONTACT AND INHALATION OF DUST,
FUME, MISTS, OR VAPORS ASSOCIATED WITH THE PRODUCT.
Other Precautions:PROTECT FROM FREEZING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WITH SATIFACTORY VENTILATION, RESPIRATORY
PROTECTION NOT USUALLY REQUIRED.
Ventilation:GENERAL ROOM VENTILATION IS USUALLY SATISFACTORY, USE LOCAL
EXHAUST VENTILATION WHEN NECESSARY.
Other Protective Equipment:WEAR DISPOSABLE GARMENTS IF DIRECT SKIN
CONTACT IS ANTICIPATED.
Work Hygienic Practices:WASH AFTER HANDLING AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
pH:3.5-7
Solubility in Water:FREELY SOLUBLE
Appearance and Odor:CLEAR, COLORLESS SOLUTION. ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:PROTECT FROM FREEZING.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF WASTE IN ACCORDANCE WITH LOCAL, STATE
AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PROFECTION ADVANCED FLOOR COATING #512
Preparer's Name:F.C.
CAGE:93607
CAGE:93607
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: PROP.
Other REC Limits:NONE RECOMMENDED
Ingred Name:ACRYLIC ACID POLYMER
CAS:25987-66-0
Fraction by Wt: PROP.
Other REC Limits:NONE RECOMMENDED
Ingred Name:DIETHYLENE GLYCOL MONOMETHYL ETHER
CAS:111-77-3
RTECS #:KL6125000
Fraction by Wt: PROP.
Other REC Limits:NONE RECOMMENDED
Ingred Name:TRIBUTOXYETHYLPHOSPHATE (LD50 ORAL=9.5 G/KG)
CAS:78-51-3
RTECS #:KJ9800000
Fraction by Wt: PROP.
Other REC Limits:NONE RECOMMENDED
Ingred Name:PHTHALIC ACID, DIBUTYL ESTER
CAS:84-74-2
RTECS #:TI0875000
Fraction by Wt: PROP.
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:POLYETHYLENE EMULSION
CAS:67892-91-5
Fraction by Wt: PROP.
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN/EYES: MAY IRRITATE. INGESTION:
MAY CAUSE SEVERE GASTRIC DISTRESS & BLOCKAGE.
Medical Cond Aggravated by Exposure:NONE
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER AT LEAST 15 MINUTES. GET MEDICAL AID.
SKIN: FLUSH THOROUGHLY W/WATER. IF IRRITATION PERSISTS, GET MEDICAL
AID. INGESTION: INDUCE VOMITING. GET MEDICAL AID.
===================== Fire Fighting Measures =====================
Flash Point Method:TOC
Flash Point:NONE TO BOILING
Lower Limits:NA
Upper Limits:NA
Unusual Fire/Explosion Hazard:HEATED MATERIAL MAY LIBERATE TOXIC FUMES;
WEAR SCBA.
================== Accidental Release Measures ==================
Spill Release Procedures:RECONTAINERIZE BY MOPPING, WET VACUUM OR
SUITABLE ABSORBENT. RINSE REMAINING MATERIAL TO DRAINS. BE CAUTIOUS
OF SLIPPERY FLOORS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE BETWEEN 40-140F.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. FOR SALE TO, USE &
STORAGE BY SERVICE PERSONNEL ONLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED
Ventilation:LOCAL
Other Protective Equipment:NONE
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:=WATER
Vapor Density:=WATER
Spec Gravity:1.051
pH:8.2
Evaporation Rate & Reference:=WATER
Solubility in Water:DISPERSES
Appearance and Odor:OPAQUE, WHITE LIQUID W/ACRYLIC ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS & OXIDIZERS
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:CARBON OXIDES & ACRYLATES
==================== Disposal Considerations ====================
Waste Disposal Methods:IN ACCORDANCE W/FEDERAL, STATE, LOCAL
REGULATIONS.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:SHEET FED OIL BASE OFFSET INK, 59469
CAGE:HO951
CAGE:1BT21
CAGE:HO951
============= Composition/Information on Ingredients =============
Ingred Name:ALIPHATIC HYDROCARBON (HYDROTREATED)
Fraction by Wt: 18-23%
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3
Ingred Name:DISTILLATES (PETROLEUM) HYDROTREATED MIDDLE; (SEVERELY
HYDROTREATED BASESTOCK)
CAS:64742-46-7
RTECS #:JN9379645
Fraction by Wt: 2-6%
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INGEST: MAY CAUSE IRRITATION OR
GASTRIC DISTURBANCE. EYE: MAY CAUSE IRRITATION. SKIN: PROLONGED
SKIN CONTACT MAY CAUSE DERMATITIS AND LOCAL IRRITATION IN SENSITIVE
INDIVIDUALS. INHAL: MAY CAUSE DIZZINESS, NAUSEA, PNEUMONIA, AND
COMA.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:MAY CAUSE SKIN AND EYE IRRITATION, AND
DIZZINESS, NAUSEA.
Medical Cond Aggravated by Exposure:SKIN CONDITIONS.
======================= First Aid Measures =======================
First Aid:INGEST: DO NOT INDUCE VOMITING, CONSULT A PHYSICIAN. EYE:
FLUSH WITH WATER FOR AT LEAST 15 MINUTES. CONSULT A PHYSICIAN.
SKIN: WASH WITH SOAP AND WATER. IF IRRITATION PERSISTS, CALL A
PHYSICIAN. INHAL : REMOVE TO FRESH AIR. APPLY OXYGEN IF NEEDED.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:>200F,>93C
Lower Limits:1.1%
Upper Limits:6%
Extinguishing Media:WATER FOG/FOAM/CO*2/DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:DENSE SMOKE MAY BE GENERATED WHILE
BURNING.
================== Accidental Release Measures ==================
Spill Release Procedures:WIPE UP WITH ABSORBENT MATERIAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTRS CLSD WHEN NOT IN USE. KEEP
CONTRS AWAY FROM EXCESSIVE HEAT, SPARKS AND OPEN FLAME. WASH HANDS
& FACE W/SOAP & WATER BEFORE EAT/SMOKING.
Other Precautions:FOR INDUSTRIAL USE ONLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NORMALLY REQUIRED. USE NIOSH/MSHA APPROVED
RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:MECHANICAL (GENERAL): ACCEPTABLE.
Other Protective Equipment:APRONS, BOOTS, IMPERVIOUS CLOTHING AS NEEDED
TO AVOID EXCESSIVE SKIN CONTACT.
Work Hygienic Practices:WASH HANDS AND FACE WITH SOAP AND WATER BEFORE
EATING/SMOKING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Vapor Density:>1
Spec Gravity:1.100(H*2O=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:VARIOUS/INK VARNISH
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING MATERIAL.
Stability Condition to Avoid:EXCESSIVE HEAT.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE AND
SMOKE.
==================== Disposal Considerations ====================
Waste Disposal Methods:I/A/W LOCAL, STATE AND FEDERAL REGULATIONS FOR
OILY WASTE.
| 1 | gloves_mandatory |
=======================================================
Product ID: 39527S, 3M CHROME & METAL RESTORER POLISH
Cage: UO659
Resp. Party Other MSDS No.: DOCUMENT: 06-8551-1
=======================================================
Contractor Summary
=======================================================
Cage: UO659
=======================================================
Ingredients
=======================================================
Cas: 112-80-1
RTECS #: RG2275000
% low Wt: 5.
% high Wt: 10.
------------------------------
Cas: 1336-21-6
RTECS #: BQ9625000
% low Wt: 1.
% high Wt: 5.
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
------------------------------
Cas: 93-82-3
% low Wt: 1.
% high Wt: 5.
-----------------------------
Cas: 7732-18-5
RTECS #: ZC0110000
% low Wt: 30.
% high Wt: 60.
------------------------------
Cas: 64742-47-8
RTECS #: OA5504000
% low Wt: 10.
% high Wt: 30.
------------------------------
Cas: 1344-28-1
RTECS #: BD1200000
% low Wt: 30.
% high Wt: 60.
OSHA PEL: 15 MG/M3
ACGIH TLV: 10 MG/M3
ACGIH STEL: NOT ESTABLISHED
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NOT PROVIDED BY MFR
Effects of Exposure: EYE: MILD EYE IRRITATION. SKIN: MILD SKIN IRRITATION
(AFTER PROLONGED OR REPEATED CONTACT). INHALATION: IRRITATION (UPPER
RESPIRATORY). PROLONGED OR REPEATED OVEREXPOSURE, ABOVE RECOMMENDED
GUIDELINES , MAY CAUSE: CENTRAL NERVOUS SYSTEM DEPRESSION. IF SWALLOWED:
INGESTION MAY CAUSE: IRRITATION OF GASTROINTESTINAL TISSUES. CENTRAL NERVOUS
SYSTEM DEPRESSION.
Explanation Of Carcinogenicity: NOT PROVIDED BY MFR
Signs And Symptions Of Overexposure: EYE-REDNESS, SWELLING, PAIN, &
TEARING. SKIN-REDNESS, SWELLING, & ITCHING. INHALATION-SORENESS OF THE
NOSE & THROAT, COUGHING & DROWSINESS, INCOORDINATION, SLOWED REACTION
TIME, SLURRED SPEECH, GIDDIN ESS & UNCONSCIOUSNESS. INGESTION-IRRITATION
OF GASTROINTESTINAL TISSUES: PAIN, VOMITING, ABDOMINAL TENDERNESS, NAUSEA,
BLOOK IN VOMITUS, & BLOOD IN FECES. CENTRAL NERVOUS SYSTEM DEPRESSION:
HEADACHE, DIZZINESS, DROWSINESS, MUSCULAR WEAKNESS, INCOORDINATION, SLOWED
REACTION TIME, FATIGUE, BLURRED VISION, SLURRED SPEECH, GIDDINESS, TREMORS
& CONVULSIONS.
First Aid: EYE: IMMEDIATELY FLUSH EYES WITH LARGE AMOUNTS OF WATER. GET
IMMDIATE MEDICAL ATTENTION. SKIN: FLUSH SKIN WITH LARGE AMOUNTS OF WATER. IF
IRRITATION PERSISTS, GET MEDICAL ATTENTION. INHALATION: IF SIG NS/SYMPTOMS
OCCUR, REMOVE PERSON TO FRESH AIR. IF SIGNS/SYMPTOMS CONTINUE, CALL A
PHYSICIAN. IF SWALLOWED: DO NOT INDUCE VOMITING. DRINK TWO GLASSES OF WATER.
CALL A PHYSICIAN.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: OBSERVE PRECAUTIONS FROM OTHER SECTIONS. VENTILATE
AREA. CONTAIN SPILL. COVER WITH ABSORBENT MATERIAL. COLLECT SPILLED MATERIAL.
CLEAN UP RESIDUE WITH WATER. PLACE IN A CLOSED CONTAINER.
Waste Disposal Methods: INCINERATE IN AN INDUSTRIAL OR COMMERICAL FACILITY IN
THE PRESENCE OF A COMBUSTIBLE MATERIAL. SINCE REGULATIONS VARY, CONSULT
APPLICABLE REGULATIONS OR AUTHORIIES BEFORE DISPOSAL. U.S. EPA HAZARDOUS W
ASTE NUMBER=NONE (NOT U.S. EPA HAZARDOUS).
Handling And Storage Precautions: RECOMMENDED STORAGE: STORE AT TEMPERATURES
ABOVE 32 DEG F (0 DEG C). KEEP CONTAINER CLOSED WHEN NOT IN USE. KEEP OUT OF
THE REACH OF CHILDREN. FIRE & EXPLOSION AVOIDANCE: KEEP CONTAINER TIGTLY
CLOSED. KEEP AWAY FROM HEAT, SPARKS, OPEN FLAME, & OTHER SOURCES OF
IGNITION.
Other Precautions: FOR TECHNICAL SERVICE & PRODUCT INFORMATION/SUPPORT,
CALL 1-877-366-2746 (1-877-3M MARINE). NFPA HAZARD CODES: HEALTH-1, FIRE-1,
REACTIVITY-0. UNUSUAL REACTION HAZARD-NONE.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point: >104.4C, 220.F
Autoignition Temp Text: N/D
Lower Limits: N/D
Upper Limits: N/D
Extinguishing Media: WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures: WEAR FULL PROTECTIVE CLOTHING, INCLUDING HELMET, SELF
CONTAINED, POSITIVE PRESSURE OR PRESSURE DEMAND BREATHING APPARATUS, BUNKER
COAT AND PANTS, BANDS AROUND ARMS, WAIST AND LEGS, FACE MASK, AND PROT ECTIVE
COVERING FOR EXPOSED AREAS OF THE HEAD.
Unusual Fire/Explosion Hazard: NONE KNOWN.
=======================================================
Control Measures
=======================================================
Respiratory Protection: AVOID PROLONGED BREATHING OF VAPORS.
Ventilation: USE IN WELL-VENTILATED AREA.
Other Protective Equipment: AVOID PROLONGED OR REPEATED SKIN CONTACT. WEAR
Work Hygienic Practices: AVOID EYE CONTACT DO NOT INGEST
Supplemental Safety and Health: TRADE NAME: 3M CHROME & METAL RESTORER
POLISH, PN/ 39527, 38527, 39527S. DOCUMENT: 06-8551-1.
=======================================================
Physical/Chemical Properties
=======================================================
HCC: V5
B.P. Text: 150 TO 212 DEG F
M.P/F.P Text: N/D
Vapor Pres: < 16 MM HG
Vapor Density: >1 (AIR=1)
Volatile Org Content %: 18
Spec Gravity: 1.09 WATER=1
PH: CA. 9.4
Viscosity: N/D
Evaporation Rate & Reference: >1 WATER=1
Solubility in Water: MODERATE
Appearance and Odor: PASTE, SLIGHT AMMONIA, PINK
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Materials To Avoid: STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products: CARBON MONOXIDE AND CARBON DIOXIDE, TOXIC
VAPORS, GASES OR PARTICULATES.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: WILL NOT OCCUR
=======================================================
Toxicological Information
=======================================================
Toxicological Information: VOLATILE ORGANIC COMPOUNDS: 18.0% BY WT. VOLATILE
ORGANIC COMPOUNDS: 1.63 LB/GAL CALCULATED PER SCAQMD RULE 443.1. VOLATILE
ORGANIC COMPOUNDS: 196 GMS/LITER CALCULATED PER SCAQMD RULE 443.1. VOC LES S
H2O & EXEMPT SOLVENTS: 328 GMS/LITYER CALCULATED PER SCAQMD RULE 443.1.
=======================================================
Ecological Information
=======================================================
Ecological: ENVIRONMENTAL DATA: NOT DETERMINED.
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
Sara Title III Information: THIS PRODUCT CONTAINS THE FOLLOWING TOXIC CHEMICAL
OR CHEMICALS SUBJECT TO THE REPORTING REQUIREMENTS OF SECTION 313 OF TITLE
III OF THE EMERGNCY PLANNING & COMMUNITY RIGHT-TO-KNOWN ACT OF 1986 &
40 C FR PART 372: AMMONIUM HYDROXIDE. EPCRA HAZARD CLASS: FIRE HAZARD-NO.
PRESSURE-NO. REACTIVITY-NO. ACUTE-YES. CHRONIC-NO.
Federal Regulatory Information: THE COMPONENTS OF THIS PRODUCT ARE IN
COMPLIANCE WITH THE CHEMICAL NOTIFICATION REQUIREMENTS OF TSCA. ALL
ALLPICABLE CHEMICAL INGREDIENTS IN THIS MATERIAL ARE LISTED ON THE EUROPEAN
INVENTORY OF EXIST ING CHEMICAL SUBSTANCES (EINECS), OR ARE EXEMPT POLYMERS
WHOSE MONOMERS ARE LISTED ON EINECS.
=======================================================
Other Information
=======================================================
=======================================================
Transportation Information
=======================================================
Trans ID NO: 159930
Product ID: 39527S, 3M CHROME & METAL RESTORER POLISH
Review Date: 11/18/2001
Multiple KIT Number: 0
Review IND: Y
Unit Of Issue: CY
Type Of Container: CYLINDER
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: ZZZ
DOT Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: ZZZ
IMO Proper Shipping Name: NOT REGULATED FOR THIS MODE OF TRANSPORTATION
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: ZZZ
IATA Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: ZZZ
AFI Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
HAZCOM Label
=======================================================
Product ID: 39527S, 3M CHROME & METAL RESTORER POLISH
Cage: UO659
Assigned IND: Y
Company Name: 3M AUTOMOTIVE AFTERMARKET DIVISION
Street: 3M CENTER
Zipcode: 55144-1000
Label Required IND: Y
Date Of Label Review: 11/18/2001
Status Code: A
Origination Code: F
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: NO
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: EYE: MILD EYE IRRITATION. SKIN: MILD SKIN IRRITATION
(AFTER PROLONGED OR REPEATED CONTACT). INHALATION: IRRITATION (UPPER
RESPIRATORY). PROLONGED OR REPEATED OVEREXPOSURE, ABOVE RECOMMENDED
GUIDELINES , MAY CAUSE: CENTRAL NERVOUS SYSTEM DEPRESSION. IF SWALLOWED:
INGESTION MAY CAUSE: IRRITATION OF GASTROINTESTINAL TISSUES. CENTRAL NERVOUS
SYSTEM DEPRESSION.
=======================================================
| 1 | gloves_mandatory |
=======================================================
Product ID: TINCTURE OF BENZOIN, 4363
Cage: 4T844
Resp. Party Other MSDS No.: S42450
=======================================================
Contractor Summary
=======================================================
Cage: 4T844
=======================================================
Item Description Information
=======================================================
=======================================================
Ingredients
=======================================================
Cas: 64-17-5
RTECS #: KQ6300000
Percent by Wt: 75.
OSHA PEL: 1900 MG/M3;1000 PPM
ACGIH TLV: 1880 MG/M3;1000 PPM
ACGIH STEL: NOT ESTABLISHED
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: NO
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: SKIN: REPEATED CONTACT MAY CAUSE IRRITATION. EYES: WILL
STING EYES. INHALATION: NONE. INGESTION: NOT KNOWN.
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
First Aid: SKIN: DISCONTINUE USE IF RASH OR IRRITATION OCCURS. EYE: FLUSH WITH
COLD WATER FOR AT LEAST 15 MINUTES. INHALATION: NONE. REMOVE TO FRESH AIR.
SUPPORT BREATHING (GIVE OXYGEN OR ARTIFICIAL RESPIRATION (FP N). INGESTION:
NOT KNOWN. CALL MD IMMEDIATELY (FP N). TARGET ORGANS: NOT KNOWN.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: ELIMINATE INGITION SOURCES.
Waste Disposal Methods: FOLLOWLOCAL, STATE AND FEDERAL REGULATIONS. TREAT AS
FLAMMABLE WASTE.
Handling And Storage Precautions: STORE IN COOL AREA. AVOID SPARKS AND OPEN
FLAME.
Other Precautions: NONE.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: OC
Flash Point: =23.9C, 75.F
Extinguishing Media: ANY. MEDIA SUITABLE FOR SURROUNDING FIRE (FP N).
Fire Fighting Procedures: USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N). HANDLE AS FLAMMABLE LIQUID.
Unusual Fire/Explosion Hazard: HAZARD RATING (NFPA): HEALTH: 1, FLAMMABILITY:
3, REACTIVITY: 0, SPECIFIC: NONE.
=======================================================
Control Measures
=======================================================
Respiratory Protection: USE NIOSH APPROVED RESPIRATOR IF PERMISSIBLE EXPOSURE
LEVEL IS EXCEEDED.
Ventilation: NONE REQUIRED IF PERMISSIBLE EXPOSURE LEVEL ISN'T EXCEEDED.
Other Protective Equipment: EYE WASH & DELUGE SHOWER MEETING ANSI DESIGN
CRITERIA (FP N).
Work Hygienic Practices: GOOD HOUSEKEEPING PRACTICES SHOULD BE FOLLOWED.
=======================================================
Physical/Chemical Properties
=======================================================
Spec Gravity: 870-.885 (H*2O=1)
Solubility in Water: INSOLUBLE
Appearance and Odor: APPLICATOR SATURATED WITH DARK BROWN LIQUID WITH
CHARACTERISTIC ODOR.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE.
Materials To Avoid: N/A.
Hazardous Decomposition Products: N/A.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: WILL NOT OCCUR.
=======================================================
Toxicological Information
=======================================================
=======================================================
=======================================================
DOT SHIPPING NAME: CONSUMER COMMODITY. TECHNICAL SHIPPING NAME: N/A. DOT
SHIPPING CLASSIFICATION: ORM-D. DOT ID NO: N/A. DOT LABEL REQUIREMENTS: N/A.
UN/NA NUMBER REGULATIONS: REPORTABLE QUANTITY:
=======================================================
Regulatory Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: TINCTURE OF BENZOIN, 4363
Cage: 4T844
Company Name: PDI-PROFESSIONAL DISPOSABLES INC DIV NICE-PAK PRODUCTS, INC.
Street: 2 NICE- PAK PARK
Zipcode: 10962-1376
Label Required IND: Y
Date Of Label Review: 11/02/1999
Status Code: A
Origination Code: F
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: Severe
Reactivity Hazard: None
Hazard And Precautions: FLAMMABLE! ACUTE: SKIN: REPEATED CONTACT MAY CAUSE
IRRITATION. EYES: WILL STING EYES. INHALATION: NONE. INGESTION: NOT KNOWN.
CHRONIC: NONE SPECIFIED BY MANUFACTURER (FP N).
=======================================================
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:AR 409 ORANGE PEEL ADHESIVE REMOVER
Preparer's Name:PAT DIAMOND
CAGE:04SM4
CAGE:04SM4
============= Composition/Information on Ingredients =============
Ingred Name:-1-METHYL-4-(1-METHYLETHENYL)CYCLOHEXENE, CARVENE, CINENE,
D-LIMONE (ANIMAL LIMITED EVIDENCE, NTP & IARC GROUP 3) *96-3*
CAS:5989-27-5
RTECS #:GW6360000
Fraction by Wt: >45%
Ingred Name:NONYLPHENOL POLYOXYETHYLENE ETHER; POLYOXYETHYLENE
NONYLPHENOL; TERGITOL NPX; TRITON N-100; NONIONIC SURFACTANT
*96-3*
CAS:9016-45-9
RTECS #:MD0900000
Fraction by Wt: <10%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHALATION: HARMFUL & IRRITATION TO
UPPER RESPIRATORY TRACT. SKIN/EYES: IRRITATION. INGESTION: HARMFUL
IF MATERIAL IS ASPIRATED INTO THE LUNGS.
Explanation of Carcinogenicity:SEE INGREDIENTS.
Effects of Overexposure:IRRITATION.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR 15 MINS. SKIN: WASH W/SOAP & WATER.
INHALATION: REMOVE TO FRESH AIR. GIVE OXYGEN IF NEEDED. INGESTION:
DRINK WATER. DON'T INDUCE VOMITING UNLESS DIRECTED BY A PHYSICIAN.
OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:113-130F
Lower Limits:0.7
Upper Limits:6
Extinguishing Media:FOAM, DRY CHEMICAL
Fire Fighting Procedures:AVOID DIRECT CONTACT W/WATER.
Unusual Fire/Explosion Hazard:DENSE BLACK SMOKE PRODUCED. AUTOIGNITION
TEMP: 459F.
================== Accidental Release Measures ==================
Spill Release Procedures:SOAK UP LIQUID W/INERT ABSORBING MATERIAL &
CONTAIN.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT & OTHER IGNITION
SOURCES. STORE IN COOL, DRY PLACE. VENT CONTAINER FREQUENTLY IF NOT
USED REGULARLY.
Other Precautions:WASH THOROUGHLY W/SOAP & WATER AFTER HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED.
Ventilation:GOOD GENERAL VENTILATION.
Other Protective Equipment:EYE BATH, SAFETY SHOWER
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>300F
Vapor Pres:2
Vapor Density:>1
Spec Gravity:<1
Evaporation Rate & Reference:(BU AC =1): <1
Solubility in Water:INSOLUBLE
Appearance and Odor:CLEAR LIQUID W/ORANGE FRAGRANCE.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS, ACIDS, PEROXIDES, HALOGENS, VINYL CHLORIDES, IODINE
PENTA FLUORIDE.
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAMES.
Hazardous Decomposition Products:NONE
Conditions to Avoid Polymerization:HIGH TEMP CONTACT W/REACTIVE
MONOMERS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:190 1008,POTASSIUM FERRICYANIDE
CAGE:19139
CAGE:19139
============= Composition/Information on Ingredients =============
Ingred Name:FERRATE(3-),HEXACYANO-TRIPOTASSIUM(CAS #13746-66-2)
CAS:13746-66-2
RTECS #:LJ8225000
Fraction by Wt: 100%
===================== Hazards Identification =====================
Effects of Overexposure:LOW HAZARD
======================= First Aid Measures =======================
First Aid:NONE INDICATED
===================== Fire Fighting Measures =====================
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP AND PLACE IN A DRUM.VACUUM THE
REMAINDER AND PLACE IN SAME DRUM.DISPOSE THROUGH LICENSED CHEMICAL
WASTE DISPOSAL SERVICE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY,WELL VENTED,LOW FIRE
RISK AREA.PROTECT FROM PHYSICAL DAMAGE.KEEP CONTAINERS CLOSED.AVOID
STRONG MINERAL ACIDS
Other Precautions:CONTAINERS HAZARDOUS WHEN EMPTY(RETAIN(S) PRODUCT
RESIDUE(S).AVOID PROLONGED OR REPEATED CONTACT.REMOVE AND WASH
CONTAMINATED CLOTHING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED
Ventilation:MECHANICAL(GEN)/LOCAL EXHAUST RECOMMENDED
Other Protective Equipment:NORMAL FULL WORK CLOTHING COVERING
ARMS,HANDS AND LEGS.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:>1
Solubility in Water:APPRECIABLE
Appearance and Odor:ORANGE PORDER;ODORLESS
Percent Volatiles by Volume:NEG
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG MINERAL ACIDS
Stability Condition to Avoid:HIGH HEAT PRODUCES HIGH TOXIC COMPOUNDS
Hazardous Decomposition Products:CYANIDE GAS
==================== Disposal Considerations ====================
Waste Disposal Methods:PLACE MATERIAL IN DRUMS SUITABLE FOR
DISPOSABLE.DISPOSE THROUGH CHEMICAL WASTE SERVICE.FEDERAL.STATE AND
LOCAL LAWS TAKE PRECEDENCE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:15662 TM RCOP ROLL COAT CLEAR
CAGE:SERIC
CAGE:SERIC
CAGE:SSERI
============= Composition/Information on Ingredients =============
Ingred Name:ACETIC ACID, C6-8-BRANCHED ALKYL ESTERS, C3-8-BRANCHED
ALKYL ESTERS ACETIC ACID
CAS:90438-79-2
Ingred Name:CYCLOHEXANONE, KETOHEXAMETHYLENE
CAS:108-94-1
RTECS #:GW1050000
Other REC Limits:100PPM (SKIN) STEL
OSHA PEL:50 PPM
ACGIH TLV:100 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:DIBASIC ESTER
Ingred Name:HEAVY AROMATIC SOLVENT NAPHTHA PETROLEUM *97-4*
CAS:64742-94-5
RTECS #:WF3100000
Ingred Name:PIGMENTS
Ingred Name:VOLATILE ORGANIC CONTENT: 779 G/L
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INGESTION: IRRITATION OF DIGESTIVE
TRACT. NERVOUS SYTEM DEPRESSION. ASPIRATION DURING
SWALLOWING/VOMITING CAN CAUSE LUNG INFLAMMATION/DAMAGE. SKIN:
PROLONGED/REPEATED OVEREXPOSURE MAY CAUSE DERMATITIS /ABSORPTION.
EYES: SEVERE IRRITANT/BLURRED VISION. INHALATION: NOSE/RESPIRATORY
TRACT IRRITATION. LIVER/KIDNEY DAMAGE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, NAUSEA, VOMITING, DIARRHEA,
DROWSINESS, DIZZINESS, LOSS OF COORDINATION, FATIGUE, INFLAMMATION,
HEADACHES, REDNESS, BURNING, DEFATTING OF SKIN, TEARING, BLURRED
VISION.
Medical Cond Aggravated by Exposure:PRE-EXISTING LUNG DISORDERS,
ASTHMA-LIKE CONDITIONS, SENSITIZATIN, ALLERGIES.
======================= First Aid Measures =======================
First Aid:INGESTION: DRINK 2 GLASSES OF WATER TO DILUTE. DON'T INDUCE
VOMITING. NEVER GIVE ANYTHING BY MOUTH IF UNCONSCIOUS. SKIN: WASH
THOROUGHLY W/SOAP & WATER. INHALATION: REMOVE TO A WELL VENTILATED
AREA. G IVE OXYGEN/CPR IF NECESSARY. EYES: FLUSH W/COPIOUS AMOUNTS
OF WATER FOR 15 MINS. OBTAIN MEDICAL ATTENTION IN ALL CASES.
TREATMENT SHOULD BE DIRECTED AT CONTROL OF SYMPTOMS & CLINICAL
CONDITION.
===================== Fire Fighting Measures =====================
Flash Point:>110F
Extinguishing Media:ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG
Fire Fighting Procedures:WEAR FULL PROTECTIVE EQUIPMENT. WATER MAY BE
UNSUITABLE FOR BURNING LIQUIDS. IF WATER IS USED, FOG NOZZLES ARE
PREFERRED. WATER MAY BE USED TO COOL CONTAINERS.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE
FROM IGNITION SOURCES & HOT SURFACES. CLOSED CONTAINERS MAY
RUPTURE/EXPLODE WHEN EXPOSED TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:USING NON-SPARKING TOOLS, PLACE LEAKING
CONTAINERS IN A WELL VENTILATED AREA. AVOID BREATHING VAPORS.
ELIMINATE ALL SOURCES OF HEAT, SPARKS/IGNITION.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID PROLONGED STORAGE AT
TEMPERATURES IN EXCESS OF 100F.
Other Precautions:DON'T BREATHE VAPORS/SPRAY MISTS. MINIMIZE SKIN
CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR AN APPROPRIATE, PROPERLY FITTED RESPIRATOR
(NIOSH/MSHA APPROVED) DURING & AFTER APPLICATION UNLESS AIR
MONITORING DEMONSTRATES VAPOR/MIST LEVELS ARE BELOW APPLICABLE
LIMITS.
Ventilation:LOCAL EXHAUST: TO CONTROL EXPOSURE TO MIST/AEROSOLS.
GENERAL EXHAUST TO MINIMIZE EXPOSURE TO VAPORS.
Other Protective Equipment:IMPERMEABLE APRONS, BOOTS, SAFETY SHOWER,
EYE BATH
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH HANDS BEFORE EATING, USING TOBACCO PRODUCTS/USING THE
WASHROOM.
Supplemental Safety and Health
TOBACCO & FOOD SHOULD BE CONSUMED IN DESIGNATED AREAS ONLY.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:312.8-419F
Vapor Density:>1
Evaporation Rate & Reference:SLOWER THAN DIETHYL ETHER
Appearance and Odor:SOLVENT EVAPORATIVE SCREEN INK
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, OXIDIZERS, ALKALI METAL HYDROXIDES
Stability Condition to Avoid:HEAT, SPARKS, ELECTRICAL EQUIPMENT, OPEN
FLAMES & OTHER IGNITION SOURCES
Hazardous Decomposition Products:CO, CO2, MIXED OXIDES OF NITROGEN,
METHYL METHACRYLATE, N-BUTYL METHACRYLATE/HYDROGEN CHLORIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PETROLEUM WAX:USW#135-140
CAGE:LO157
CAGE:4W679
CAGE:LO157
============= Composition/Information on Ingredients =============
Ingred Name:PETROLEUM WAX BLEND (PER MFR,TAKE TLV AS OIL MIST =5MG/CUM)
Fraction by Wt: 100%
===================== Hazards Identification =====================
Effects of Overexposure:EYES:MILD IRRIT;SKIN:WILL SOFTEN CALLOUSED
SKIN;INHAL:RESP.TRACT IRRIT.INGEST:MAY ACT AS LAXATIVE.
======================= First Aid Measures =======================
First Aid:INHALE:REMOVE TO FRESH AIR, GIVE CPR/O*2 IF
NEED;EYES/SKIN:FLUSH W LG AMTS H*2O FOR 15 MIN;INGEST:RINSE MOUTH;
GET MEDICAL ATTENTION FOR EYES, BREATHING DIFFICULTY, OR OTHER
SYMPTOMS OF OVEREXPOSURE.
===================== Fire Fighting Measures =====================
Flash Point:>400F/204C
Extinguishing Media:FOAM,DRY CHEMICAL,CO*2,WATERFOG
Fire Fighting Procedures:TREAT AS OIL FIRE;USE NIOSH/MSHA APPROVED SCBA
IN CONFINED A
Unusual Fire/Explosion Hazard:PRODUCTS OF COMBUSTION-SMOKE,CO & CO*2
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION;SCRAPE UP
MATERIAL INTO WASTE CONTAINERS.CLEAN THE AREA WITH DETERGENT.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN SEALED CONTAINERS AWAY FROM
HEAT,OPEN FLAME & OXIDIZING MATERIALS.
Other Precautions:AVOID PERSONAL CONTACT;WASH WITH SOAP AND WATER AFTER
EACH USE.DO NOT SMOKE,EAT OR DRINK IN WORK AREA.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR FOR
ORG.VAPORS/MIST IF ABOVE TLV.
Ventilation:MECH(GEN)OR LOCAL EXHAUST THAT PROVIDES ADEQUATE
VENTILATION
Other Protective Equipment:FULL WORK CLOTHING TO PREVENT REPEATED OR
PROLONGED CONTACT.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Vapor Pres:NIL
Spec Gravity:0.8035
Evaporation Rate & Reference:0.0 (ETHYL ETHER=1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:WHITE WAX (SOLID AT ROOM TEMP.)ODORLESS
Percent Volatiles by Volume:0.0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:EXTREME HEAT,OPEN FLAME
Hazardous Decomposition Products:NONE NOTED BY MFR.PROD OF
COMBUSTION:CO AND CO*2 OR SMOKE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF COLLECTED MATERIAL IN ACCORDANCE WITH
LOCAL,STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:BIO-CLEANSE PART 1
CAGE:0P975
CAGE:0P975
============= Composition/Information on Ingredients =============
Ingred Name:2-BUTOXYETHANOL (SARA III)
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: 4-6%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM; 9394
Ingred Name:SODIUM HYDROXIDE (SARA III)
CAS:1310-73-2
RTECS #:WB4900000
Fraction by Wt: 1-3%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:2 MG/M3
ACGIH TLV:C 2 MG/M3; 9394
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SODIUM METASILICATE
CAS:6834-92-0
RTECS #:VV9275000
Fraction by Wt: 4-6%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: CONTACT MAY CAUSE SKIN & EYE
IRRITATION. IF INGESTED, MAY CAUSE CORROSIVE DAMAGE TO MOUTH,
THROAT & STOMACH. NO HEALTH EFFECTS NOTED FOR INHALATION. CHRONIC:
PROLONGED OR REPEATED EXPOSURE MAYCAUSE SKIN IRRITATION.
Explanation of Carcinogenicity:NO INGREDIENT OF A CONCENTRATION OF 0.1%
OR GREATER IS LISTED AS A CARCINOGEN OR SUSPECTED CARCINOGEN.
Effects of Overexposure:SKIN-IRRITATION. EYES-IRRITATION.
INGESTED-STOMACH PAIN, BURNS TO MOUTH & THROAT, NAUSEA, VOMITING.
Medical Cond Aggravated by Exposure:NONE KNOWN TO DOMINION RESTORATION.
======================= First Aid Measures =======================
First Aid:EYES-FLUSH WITH WATER FOR 15 MINUTES. IF IRRITATION PERSISTS,
SEE DOCTOR. SKIN-REMOVE WITH PLENTY OF WATER. INGESTED-IF
CONSCIOUS, DRINK LARGE AMOUNTS OF WATER. GET MEDICAL ATTENTION.
INHALED-NONE SPE CIFIED BY MANUFACTURER.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WATER & WATER FOG.
Fire Fighting Procedures:DLA-HMIS: FIREFIGHTERS SHOULD WEAR FULL
PROTECTIVE CLOTHING INCLUDING POSITIVE-PRESSURE SELF-CONTAINED
BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB WITH OIL-DRI OR SIMILAR INERT MATERIAL.
SWEEP OR SCRAPE UP AND PLACE IN A CONTAINER FOR LATER DISPOSAL.
RINSE AFFECTED AREA THOROUGHLY WITH WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE AWAY FROM
STRONG MINERAL ACIDS.
Other Precautions:DO NOT STORE MIXED PRODUCT. DISPOSE OF UNUSED MIXED
PRODUCT. PLACE MIXED PRODUCT IN OPEN OR VENTED PLASTIC CONTAINER.
MIXED PRODUCT WILL EXPAND.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED.
Ventilation:IF NEEDED, USE MECHANICAL VENTILATION OR LOCAL EXHAUST TO
MAINTAIN EXPOSURE BELOW TLV(S).
Other Protective Equipment:NONE NORMALLY REQUIRED. WEAR APPROPRIATE
CLOTHING/EQUIPMENT IF SPLASHING IS NORMAL OCCURANCE.
Work Hygienic Practices:WASH HANDS AFTER USE AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:>200F,>93C
Spec Gravity:1.1
Solubility in Water:COMPLETE
Appearance and Odor:BLUE COLORED LIQUID WITH MILD ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MIXING WITH STRONG MINERAL ACIDS.
Stability Condition to Avoid:NONE KNOWN TO DOMINION RESTORATION.
Hazardous Decomposition Products:WHEN EXPOSED TO FIRE, PRODUCES NORMAL
PRODUCTS OF COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:NO SPECIAL METHOD. OBSERVE ALL LOCAL, STATE AND
FEDERAL REGULATIONS REGARDING DISPOSAL OF NON-HAZARDOUS MATERIAL.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:METHYL ETHYL KETONE
CAGE:61637
CAGE:0F2M5
CAGE:61637
============= Composition/Information on Ingredients =============
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 100%
Other REC Limits:NONE NORMALLY REQUI.
OSHA PEL:200 PPM/300 STEL
ACGIH TLV:200 PPM/300STEL 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE-EYES/SKIN:IRRITATION.
INHALATION:IRRITATION TO THE RESPIRATORY TRACT. INGESTION:
MODERATELY TOXIC. ASPIRATION INTO LUNGS MAY CAUSE CHEMICAL
PNEUMONITIS WHICH CAN BE FATAL. CHRONIC- CNS DEPRESSIO N, NARCOSIS.
Explanation of Carcinogenicity:DATA PER MSDS
Effects of Overexposure:IRRIT OF NOSE, THROAT, EYES. INHALATION:
HEADACHE, NAUSEA, DIZZINESS, AND INCOORDINATION. INGESTION: NAUSEA,
VOMITING AND DIARRHEA.
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF AILMENTS
OR WITH A PRE-EXISTING DISEASE INVOLVING THE EYES, SKIN, OR
RESPIRATORY TRACT MAY BE AT INCREASED RISK FROM EXPOSURE.
======================= First Aid Measures =======================
First Aid:INHALATION:REMOVE TO FRESH AIR. RESUSCITATE IF NOT BREATHING.
GET MEDICAL ATTENTION. EYES:IMMEDIATELY FLUSH WITH PLENTY OF WATER
FOR 15 MINUTES HOLDING EYELIDS OPEN. GET MEDICAL ATTENTION.
SKIN:REMOVE CONTAMINATED CLOTHING. WASH WITH SOAP AND WATER. IF
IRRITATION PERSISTS, GET MEDICAL ADVICE. INGESTION:DO NOT INDUCE
VOMITING. GIVE NOTHING BY MOUTH IF UNCONSCIOUS. GET IMMEDIATE
MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:21.0F,-6.1C
Lower Limits:1.8
Upper Limits:10
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:VAPORS MAY TRAVEL A LONG DISTANCE AND MAY
GET IGNITED AT LOCATIONS DISTANT FROM HANDLING POINTS.
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION; CONTAIN FREE
MATERIAL IF POSSIBLE; USE SUITABLE INERT ABSORBENT MATERIAL AND
RECOVER FOR PROPER DISPOSAL IN AN APPROVED CONTAINER.
Neutralizing Agent:NOT APPLICABLE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY, WELL VENTILATED
AREA. KEEP CONTAINERS TIGHTLY CLOSED WHEN NOT IN USE. PROTECT
CONTAINERS FROM PHYSICAL DAMAGE.
Other Precautions:DO NOT TAKE INTERNALLY. DO NOT BREATHE MIST. AVOID
PROLONGED OR REPEATED BREATHING OF VAPOR. AVOID CONTACT WITH EYES.
USE WITH ADEQUATE VENTILATION. WASH THOROUGHLY AFTER HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED RESPIRATOR AS REQUIRED IF
ABOVE PEL/TLV OR SCBA IN AN ENCLOSED AREA.
Ventilation:LOCAL/GENERAL TO MAINTAIN PEL/TLV.
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER,WORK
CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
AVOID PROLONGED OR REPEATED EXPOSURE. DO NOT GET ON SKIN OR IN EYES. DO
NOT BREATHE VAPORS OR MISTS.
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:=79.4C, 175.F
Vapor Pres:71 MMHG
Vapor Density:2.49
Spec Gravity:0.8061
Evaporation Rate & Reference:6.31 (BUTL ACT=1)
Solubility in Water:24% BY WT
Appearance and Odor:CLEAR LIQUID, NON-RESIDUAL ODOR
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALKALINE MATERIALS, MINERAL ACIDS, HALOGENS
Stability Condition to Avoid:HIGH TEMP, OPEN FLAMES.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE AND
OTHER UNIDENTIFIED COMPONENTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONSULT LOCAL AUTHORITIES. DISPOSAL MUST BE MADE
IN ACCORDANCE WITH ALL APPLICABLE FEDERAL, STATE AND LOCAL LAWS AND
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ALOX 22028CM-3
CAGE:HO484
CAGE:60773
CAGE:HO484
CAGE:33150
============= Composition/Information on Ingredients =============
Ingred Name:SOLVENT 140-HI FLASH ALOPHATIC HYDROCARBON BLEND
Fraction by Wt: 19.2%
Other REC Limits:NONE SPECIFIED
Ingred Name:INHIBITOR BLEND INCLUDING THE BARIUM SOAP OR AN OXYGENATED
HYDROCARBON
Fraction by Wt: 4.8%
Other REC Limits:NONE SPECIFIED
Ingred Name:SOLVENT FREON 113
Fraction by Wt: 72%
Other REC Limits:NONE SPECIFIED
ACGIH TLV:1000 PPM
Ingred Name:CARBON DIOXIDE
CAS:124-38-9
RTECS #:FF6400000
Fraction by Wt: 4%
Other REC Limits:NONE SPECIFIED
OSHA PEL:5000 PPM
ACGIH TLV:5000PPM/30000STEL;93
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:WARNING: VAPORIZATION OF EXCESSIVE
AMOUNT OF THIS PRODUCT CAN DELETE OR REPLACE OXYGEN NECESSARY FOR
BREATHING. IN CONFIRMED/ENCLOSED SPACES OR AREAS WITH LITTLE
VENTILATION, THIS MAY BE HAZARDOUS TO HEALTH. EXPOSURE TO HIGH
CONCENTRATIONSOF THIS PRODUCT.
Explanation of Carcinogenicity:MAY INDUCE CARDIAC ARRHYTHMIAS AT HIGH
CONCENTRATIONS.
Effects of Overexposure:LIGHT HEADEDNESS, GIDDINESS, SHORTNESS OF
BREATH, POSSIBLE NARCOSIS POSSIBLE CARDIAC ARRHYTHMIAS AT HIGH
CONCENTRATIONS.
Medical Cond Aggravated by Exposure:POSSIBLE CARDIAC ARRHYTHMIAS,
POSSIBLE NARCOSIS
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR, CALL A PHYSICIAN. DO NOT
GIVE ESPINEPHRIN OR SIMILAR DRUG. SKIN AND EYES: FLUSH WITH WATER.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:163F,73C
Extinguishing Media:MECHANICAL FOAM, DRY CHEMICALS, WATER FOG, CO2
Fire Fighting Procedures:STRAIGHT WATER STREAM WOULD SPREAD OIL FIRES
Unusual Fire/Explosion Hazard:VAPOR ACCUMULATION WOULD FLASH AND/OR
EXPLODE IF IGNITED
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA, ESPECIALLY LOW PLACES WHERE
HEAVY VAPORS MIGHT COLLECT. REMOVE OPEN FLAME.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE CONTAINERS IN A CLEAN, DRY AREA.
DO NOT HEAT ABOVE 125F.
Other Precautions:READ LABELS VERY CAREFULLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE AIR MASK IN HIGH CONCENTRATIONS.
Ventilation:WHEN LARGE AMOUNTS ARE RELEASED, ESPECIALLY IN LOW PLACES
Other Protective Equipment:NONE REQUIRED
Work Hygienic Practices:FOLLOW ALL INSTRUCTIONS
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:V4
Boiling Pt:B.P. Text:117 TO 390F
Vapor Pres:334 MMHG
Vapor Density:6.4
Spec Gravity:1.22-1.27
Evaporation Rate & Reference:.3/CARBON TETRACHLORIDE=1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:DARK AMBER WITH ORGANIC ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALKALI OR ALKALINE EARTH METALS-POWDERED AL, ZN, BE, ETC.
Stability Condition to Avoid:OPEN FLAMES OR HIGH TEMPERATURES
Hazardous Decomposition Products:HYDROCHLORIC AND HYDROFLUORIC
ACIDS-POSSIBLE CARBONYLHALIDES
==================== Disposal Considerations ====================
Waste Disposal Methods:RECLAIM BY DISTILLATION
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SYNTHITE, AC-41
CAGE:GO805
CAGE:GO805
CAGE:72688
============= Composition/Information on Ingredients =============
Ingred Name:ING 7:AMTS (MORE THAN 5 OZ IN AN ADULT) PREFERABLY W/SYRUP
OF IPECAC UNDER DIRECTION FROM A MD/POISON CENTER. (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8:IF SYRUP OF IPECAC IS NOT AVAIL, VOMIT CAN BE INDUCE
BY GENTLY PLACING TWO FINGERS IN THE BACK OF THROAT. (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9:IF POSSIBLE, DO NOT LEAVE VICTIM UNATTENDED.
RTECS #:9999999ZZ
Ingred Name:SPILL PROC:SAND/OTHER INERT MATERIAL TO DRAIN & CONTAIN
SPILL. DO NOT FLUSH AREA W/WATER; USE ABSORBENT PADS. (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11:NOTIFY APPROPRIATE AGENCIES.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC:SOURCES OF IGNITION; THAT EXPLODE & CAUSE
INJURY/DEATH. "EMPTY" DRUMS SHOULD BE COMPLETELY DRAINED. (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13:"EMPTY" DRUMS SHOULD BE COMPLETELY DRAINED, PROPERLY
BUNGED & PROMPTLY SHIPPED TO DRUM RECONDITIONER. ALL(ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14:OTHER CNTNRS SHOULD BE DISPOSED OF IN AN
ENVIRONMENTALLY SAFE MANNER & IN ACCORDANCE W/GOVT REGS. BEFORE
(ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15:WORKING ON/IN TANKS WHICH CNTN/HAVE CNTND THIS PROD,
REFER TO OSHA REGS AND/OR ANSI Z49.1 PERTAINING TO (ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16:CLEANING, WELDING OR OTHER COMTEMPLATED OPERATIONS.
RTECS #:9999999ZZ
Ingred Name:VENT:(SEE INGREDIENTS SECTION), ADDNL VENT/EXHST SYS MAY BE
REQ. WHEN EXPLO MIX MAY BE PRESENT, SYS SAFE FOR (ING 19)
RTECS #:9999999ZZ
Ingred Name:ING 18:SUCH LOCATIONS SHOULD BE USED. NO SMOKING OR OPEN
LIGHTS.
RTECS #:9999999ZZ
Ingred Name:XYLENE (SARA 313) (CERCLA) VP 6.6 @ 68F
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 55-65%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/150STEL;9495
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SUPDAT:HAZARD - THIS MATERIAL CAN ENTER LUNGS DURING
SWALLOWING OR VOMITING AND CAUSE LUNG INFLAMMATION AND DAMAGE.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC:EXPOS DEVELOP, MOVE VICTIM AWAY FROM SOURCE
OF EXPOS & INTO FRESH AIR. IF SYMPS PERSIST, SEEK (ING 4)
RTECS #:9999999ZZ
Ingred Name:ING 3:IMMED MED ATTN. IF VICTIM IS NOT BRTHG, ARTF RESP
SHOULD BE ADMINISTERED. IF BRTHG DIFFICULTIES DEVELOP, (ING 5)
RTECS #:9999999ZZ
Ingred Name:ING 4:OXYGEN SHOULD BE ADMINISTERED BY QUALIFIED PERS. SEEK
IMMED MED ATTN. INGEST:SEEK EMER MED ATTN. THIS MATL (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5:IS SLIGHTLY TOX BY INGEST & AN ASPIR HAZ. IF VICTIM
IS DROWSY/UNCON, PLACE ON THE LEFT SIDE W/HEAD DOWN. (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6:DO NOT GIVE ANYTHING BY MOUTH. IF VICTIM IS CONSCIOUS
& ALERT, VOMIT SHOULD BE INDUCED FOR INGEST OF LARGE (ING 8)
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: THIS MATERIAL IS AN IRRITANT.
DIRECT CONTACT WITH THE LIQUID OR EXPOSURE TO ITS VAPORS OR MISTS
MAY CAUSE BURNING, TEARING, REDNESS AND SWELLING. SKIN: THIS
MATERIAL MAY CAUSE SKIN IRRITATION. PR OLONGED OR REPEATED EXPOSURE
TO THIS MATERIAL MAY CAUSE REDNESS, BURNING, AND DRYING AND
CRACKING OF (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:THE SKIN. THIS PROD MAY BE ABSORBED
THRU THE SKIN. INHAL: BRTHG HIGH CONCS OF VAPS/MISTS MAY CAUSE
IRRIT OF THE NOSE & THROAT & SIGNS OF NERVOUS DEPRESS (E.G. DROW,
DIZZ, LOSS OF COORDINATION , & FATIGUE), PRLNGD/RPTD (SUPDAT)
Medical Cond Aggravated by Exposure:RESP SYS ASSOC W/PRE-EXISTING LUNG
DISORDERS (E.G. ASTHMA-LIKE CNDTNS) MAY BE AGGRAVATED BY EXPOS TO
THIS MATL. PERS W/PRE-EXISTING SKIN DISORDERS MAY BE MORE
SUSCEPTIBLE TO THE EFTS OF THIS MATL.
======================= First Aid Measures =======================
First Aid:EYE:IF IRRIT/REDNESS FROM EXPOS TO VAPS DEVELOPS, MOVE VICTIM
AWAY FROM EXPOS & INTO FRESH AIR. IF IRRIT/REDNESS PERSISTS, SEEK
MED ATTN. FOR DIRECT CNTCT, FLUSH THE AFFECTED EYE(S) W/CLEAN H*2O
FOR A T LEAST 15 MIN. SEEK MED ATTN. SKIN:REMOVE CONTAMD CLTHG.
CLEANSE AFFECTED AREA(S) THORO BY WASHING W/MILD SOAP & H*2O. IF
IRRIT/REDNESS DEVELOP & PERSISTS, SEEK MED ATTN. INHAL:IF SYMPS OF
(ING 3)
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:81.0F,27.2C
Lower Limits:1.0%
Upper Limits:7.0%
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEM. SMALL FIRES:EXTING
W/DRY CHEM, CARBON DIOXIDE/FOAM. LARGE FIRES:USE A DRY CHEM
(SUPDAT)
Fire Fighting Procedures:USE NIOSH APPRVD SCBA & FULL PROT EQUIP .
WATER SPRAY MAY BE USEFUL TO MINIMIZE VAPS & COOLING CNTNRS BUT USE
CAUTION TO PVNT SPREADING OF BURNING(SUPDAT)
Unusual Fire/Explosion Hazard:THIS MATERIAL IS FLAMMABLE AND MAY BE
IGNITED BY HEAT, SPARKS, FLAME OR STATIC ELECTRICITY.
================== Accidental Release Measures ==================
Spill Release Procedures:STAY UPWIND & AWAY FROM SPILL. KEEP ALL
SOURCES OF IGNIT & HOT METAL SURFS AWAY FROM SPILL. IF SPILL IS
INDOORS, VENT AREA OF SPILL. FOAM, ESP HIGH EXPANSION FOAM, MAY BE
USED TO SURPRESS VAPS, KEEP O UT OF DRAINS, SEWERS & WATERWAYS. USE
(ING 11)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS TIGHTLY CLOSED, COOL,
DRY & AWAY FROM SOURCES OF IGNITION, AND STORE THIS PRODUCT WITH
ADEQUATE VENTILATION.
Other Precautions:AVOID INHAL OF VAPS & PERS CNTCT W/PROD USE GOOD PERS
HYGIENE PRACTICE. "EMPTY" CNTNRS RETAIN RESIDUE & CAN BE DANGEROUS.
DO NOT PRESSURIZE, CUT, WELD, BRAZE, SOLDER, DRILL, GRIND/EXPOS
SUCH CNTNRS TO HEAT, FLAME, SPARKS/OTHER (ING 12)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:THE USE OF RESP PROT IS ADVISED WHEN CONCS EXCED
THE ESTABLISHED EXPOSURE LIMITS (SEE INGRED SECTION). DEPENDING ON
THE AIRBORNE CONC, USE A RESP/GAS MASK W/APPROP CARTRIDGES & (NIOSH
APPROVED, IF AVA IL) OR SUPPLIED AIR EQUIP.
Ventilation:IF CURRENT VENT PRACTICES ARE NOT ADEQ TO MAINTAIN AIRBORNE
CONCENTRATION BELOW THE ESTABLISHED EXPOSURE LIMITS (ING 18)
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . NEOPRENE APRON.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EXTING MEDIA:OR FOAM. H*2O MAY BE INEFT ON THIS MATL. FIRE FIGHT
PROC:LIQ BY THE COOLING H*2O. EFTS OF OVEREXP:EXPOS TO VAPS/MISTS
MAY CAUSE LIVER DMG & KIDNEY DMG. INGEST:OF EXCESSIVE QTIES MAY
CAUSE IRRIT OF THE DIGESTIVE TRACT & SIGNS OF NERVOUS DEPRESS
(E.G. DROW, LOSS OF COORDINATION, & FATIGUE). ASPIR HAZ (ING 2)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>280F,>138C
Vapor Pres:SEE ING
Vapor Density:3.7
Spec Gravity:0.94
Evaporation Rate & Reference:0.47(N BUTYL ACETATE =1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR AMBER LIQUID - AROMATIC ODOR.
Percent Volatiles by Volume:60-70
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
THIS MATERIAL IS INCOMPATIBLE WITH STRONG ACIDS OR BASES, OXIDIZING
AGENTS AND SELECTED AMINES.
Stability Condition to Avoid:HIGH TEMPERATURE STORAGE.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY YIELD CARBON
MONOXIDE, CARBON DIOXIDE, AND/OR OXIDES OF NITROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL AGENCIES.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:K-LITE BULK FIBER
Resp. Party Other MSDS Num.:93315K SERIES
CAGE:TO075
CAGE:TO075
============= Composition/Information on Ingredients =============
Ingred Name:ALUMINUM OXIDE
CAS:1344-28-1
RTECS #:BD1200000
Minumum % Wt:47.
Maxumum % Wt:53.
OSHA PEL:15 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:SILICON OXIDE (SIO2) (PEL: USE 2 FIBERS/CC=RECOMMENDED
INDUSTRIAL STANDARD.)
CAS:7631-86-9
Minumum % Wt:47.
Maxumum % Wt:53.
OSHA PEL:2 FIBERS/CC
Ingred Name:MULLITE. (AFTER USE AT ELEVATED TEMPERATURES.)
CAS:1302-93-8
Ingred Name:SILICA, CRYSTALLINE-CRISTOBALITE; (CRISTOBALITE. (AFTER USE
AT ELEVATED TEMPERATURES.))
CAS:14464-46-1
RTECS #:VV7325000
OSHA PEL:0.05 MG/M3
ACGIH TLV:0.05 MG/M3
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:LONG TERM EXPOS TO K-LITE FIBER PRODS
CAUSES NO KNOWN CHRONIC HLTH PROBS IN HUMANS. NO FED/STATE AGENCY
REGULATES OCCUP EXPOS TO UNFIRED CERAMIC FIBER. LTD TESTING W/LAB
ANIMALS HAS PRDCD INCONCLUSIVE RSLTS CONCERNING POSS CARCIN OF
CERAMIC FIBER PRIOR TO SERVICE AT ELEVATED TEMPS. EXPOS TO
RESPIRABLE DUST FROM CERAMIC FIBER PRODS SHOULD BE MIN UNTIL
FURTHER ANIMAL & HUMAN STUDIES ARE COMPLETE. IA RC HAS PLACED
CERAMIC FIBER IN CATEGORY 2B (IARC BELIEVES THERE IS SUFFICIENT
EVID OF CARCIN IN ANIMALS BUT INSUFFICIENT DATA IN HUMANS). HNDLG
CERAMIC FIBER PRODS MAY PRDCE DUST WHICH MAY CAUSE TEMPO RARY IRRIT
TO SKIN, (EFTS OF OVEREXP)
Explanation of Carcinogenicity:SILICA, CRYSTALLINE (CRISTOBALITE): IARC
MONOGRAPHS, VOL 68, PG 41, 1997: GROUP 1. NTP 8TH ANNUAL REPORT ON
CARCINOGENS, 1998: REASONABLY ANTICIPATED TO BE HUMAN CARCINOGEN.
Effects of Overexposure:HLTH HAZ: EYES, NOSE, THROAT/LUNGS. AS MFRD,
K-LITE PRODS ARE ALUMINOSILICATES WHICH MAY TRANSFORM, AFTER
SERVICE AT ELEVATED TEMPS (>1600F), TO MULLITE & CRISTOBALITE (FORM
OF CRYSTALLINE SILICA). RE MOVAL OF K-LITE PRODS AFTER SERVICE MAY
GENERATE DUST. PRLNG/RPTD INHAL OF RESPIRABLE FREE CRYSTALLINE
SILICA MAY CAUSE DELAYED LUNG INJURY (SILICOSIS). IARC HAS PLACED
CRYSTALLINE SILICA IN CATEGORY 2A (IARC BELIEVES THERE IS
SUFFICIENT EVID OF CARCIN IN ANIMALS BUT EVID FOR CARCIN TO HUMANS
IS LTD).
Medical Cond Aggravated by Exposure:MAY AGGRAVATE BRONCHIAL DISORDERS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. SKIN: WASH WITH MILD SOAP
AND WATER.INGESTION: DRING PLENTY OF WATER. EYES: FLUSH WITH
PLENTY OF WATER FOR AT LEAST 15 MINUTES AND IF IRRITATION PERSISTS,
SEE A PH YSICIAN.
===================== Fire Fighting Measures =====================
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:VACUUM CLEAN DUST WITH EQUIPMENT FITTED WITH
HEPA FILTER. IF SWEEPING IS NECESSARY, USE A DUST SUPPRESSANT
AND/OR SPRAY WITH WATER PRIOR TO SWEEPING.
======================Handling and Storage ======================
Handling and Storage Precautions:EMPLOYEES SHOULD BE PROHIBITED FROM
SMOKING IN ANY AREA WHERE CERAMIC FIBER IS BEING INSTALLED.
Other Precautions:DURING TEAR OUT/REMOVAL OF THESE PRODS, APPROP VENT &
NIOSH APPRVD RESP PROT SHOULD BE PROVIDED IN COMPLIANCE W/OSHA STDS
29 CFR 1910.94 & 1910.134 RESPECTIVELY. ADDNLY, MATL BEING TORN
OUT/REMOVED SH OULD BE SPRAYED W/WATER, PREF WATER CNTNG WETTING
AGENT (DETERGENT) TO SUPPRESS DUSTING. DUST COLLEC TION (SUPP DATA)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED DUST RESPIRATOR IN COMPLIANCE
WITH OSHA STANDARD 29 CFR 1910.134 (AIR PURIFYING, HALF-MASK OR
FULL FACEPIECE RESPIRATOR WITH APPROPRIATE FILTER PAD OR
CARTRIDGE).
Ventilation:ANY OPERATION THAT MAY GENERATE DUST SHOULD BE ISOLATED &
PROVIDED WITH ADEQUATE LOCAL EXHAUST VENTILATION PER OSHA STANDARD
29 CFR 1910.94.
Other Protective Equipment:EYE WASH & DELUGE SHOWER MEETING ANSI DESIGN
CRITERIA . LONG SLEEVED WORK SHIRT, LONG PANTS & CAP TO PREVENT
SKIN CONTACT.
Work Hygienic Practices:IRRITATION MAY RESULT FROM WEARING CONTACT
LENSES WHILE HANDLING THIS PRODUCT. WORK CLOTHING SHOULD BE WASHED
SEPARATELY.
Supplemental Safety and Health
OTHER PREC: APPARATUS SHOULD BE USED.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:>1760.C, ######F
Spec Gravity:2.73 G/M3 (H*2O=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:COTTONY WHITE FIBER; NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:AFTER SERVICE AT ELEVATED TEMPERATURES
(>1600F), MULLITE AND CRISTOBALITE (A FORM OF CRYSTALLINE SILICA)
MAY BE TRANSFORMED FROM ALUMINOSILICATES.
Conditions to Avoid Polymerization:WILL NOT POLYMERIZE.
=================== Toxicological Information===================
Toxicological Information:SEE HEALTH HAZARDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTES ARE NOT HAZARDOUS WASTES AS DEFINED BY
RCRA (40 CFR PART 261). COMPLY WITH FEDERAL, STATE AND LOCAL
REGULATIONS. METHOD OF DISPOSAL - LANDFILL. RQ - N/A. WET DOWN WITH
WATER TO PREVENT DUSTING. DO NOT TRANSPORT IN AN UNCOVERED VEHICLE
OR RECEPTACLE.
=================== MSDS Transport Information ===================
Transport Information:INTERNATIONAL: UN NUMBER: NOT REGULATED. UNITED
STATES: EPA WASTE NUMBERL D011; DOT CLASSIFICATION: NOT REGULATED.
CANADA: PIN NUMBER: NOT REGULATED; TDG CLASS: NOT REGULATED. EC:
DGL: NOT DETERMINED.
===================== Regulatory Information =====================
State Regulatory Information:WARNING: THIS PRODUCT CONTAINS A CHEMICAL
OR CHEMICALS KNOWN TO THE STATE OF CALIFORNIA TO A) CAUSE CANCER OR
B) CAUSE BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TECH TIRE AND TUBE COMPOUND, 723L
Resp. Party Other MSDS Num.:722MSD REV. NO. 2
Preparer's Name:JOHN GRAMZA, JR
CAGE:5U567
CAGE:5U567
============= Composition/Information on Ingredients =============
Ingred Name:ETHANOL, 2,2',2"-NITRILOTRI-; (TRIETHANOLAMINE)
CAS:102-71-6
RTECS #:KL9275000
Fraction by Wt: 22% BY VOL
Other REC Limits:N/K
OSHA PEL:N/K
OSHA STEL:N/K
ACGIH TLV:5 MG/M3
ACGIH STEL:N/K
Ingred Name:9-OCTADECENOIC ACID, (Z)--; (OLEIC ACID)
CAS:112-80-1
RTECS #:RG2275000
Fraction by Wt: 27% BY VOL
Other REC Limits:N/K
OSHA PEL:N/K
OSHA STEL:N/K
ACGIH TLV:N/K
ACGIH STEL:N/K
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES:EXPOSURE TO PRODUCT MAY CAUSE
EYE IRRITATION. SYMPTOMS INCLUDE STINGING, TEARING, REDNESS AND
SWELLING. INHALATION: NOT A NORMAL ROUTE OF ENTRY. INGESTION:
SINGLE DOSE ORAL TOXICITY IS LOW .SYMPTOMS MAY INCLUDE
GASTROINTESTINAL IRRITATION (NAUSEA, VOMITING, DIARRHEA). SKIN:
EXPOSURE MAY CAUSE MILD SKIN IRRITATION. PROLONGED OR REPEATED
EXPOSURE MAY DRY SKIN. SYMPTOMS INCLUDE REDNE SS, BURNING, DRYING,
CRACKING AND SKIN BURNS. TARGET ORGANS: CENTRAL NERVOUS SYSTEM,
LIVER, KIDNEYS, SKIN, EYES.
Effects of Overexposure:SEE HEALTH HAZARDS.
======================= First Aid Measures =======================
First Aid:EYES: IF SYMPTOMS DEVELOP, MOVE INDIVIDUAL AWAY FROM EXPOSURE
AND INTO FRESH AIR. FLUSH EYES WITH WATER FOR AT LEAST 15 MINUTES
WHILE HOLDING EYELIDS APART. IF SYMPTOMS PERSIST, SEEK MEDICAL
ATTENTION . INHALATION: NOT A NORMAL ROUTE OF ENTRY. REMOVE TO
FRESH AIR. SUPPORT BREATHING (GIVE OXYGEN OR ARTIFICIAL
RESPIRATION) . INGESTION: IF SWALLOWED, DRINK TWO LARGE GLASSES OF
WATER TO INDUCE VO MITING. SEEK MEDICAL ATTENTION. SKIN: WASH
EXPOSED AREA WITH SOAP AND WATER. IF SYMPTOMS PERSIST, SEEK MEDICAL
ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Extinguishing Media:WATER, FOAM, CARBON DIOXIDE OR DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:CARBON MONOXIDE AND CARBON DIOXIDE MAY
FORM AS A RESULT OF HEATING OR BURNING.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL SPILL: ABSORB MATERIAL WITH PAPER,
VERMICULITE, FLOOR ABSORBENT, OR OTHER ABSORBING MATERIAL. TRANSFER
INTO APPROVED CONTAINER FOR DISPOSAL. LARGE SPILL: DIKE AREA OF
SPILL TO PREVENT SPREADING. ABSORB WITH APPROPRIATE MATERIALS.
TRANSFER INTO APPROVED CONTAINERS FOR DISPOSAL. TOXIC TO FISH. DO
NOT DUMP INTO NATURAL WATERWAYS.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP FROM FREEZING. STORE IN SAFE
AREAS AT ROOM TEMPERATURE. DO NOT INCINERATE CONTAINERS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE REQUIRED DURING NORMAL USE. USE
NIOSH APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL OR LOCAL EXHAUST)
VENTILATION TO MAINTAIN EXPOSURE BELOW TLV(S). EXPLOSION-PROOF
VENTILATION SYSTEM IS ACCEPTABLE.
NITRILE.
Other Protective Equipment:ANSI APPROVED EMERGENCY EYEWASH AND DELUGE
SHOWER .
Work Hygienic Practices:USE GOOD PERSONAL HYGIENE WORK PRACTICES. WASH
HANDS BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES.
PROMPTLY REMOVE SOILED CLOTHING AND WASH BEFORE REUSE.
Supplemental Safety and Health
REGULATIONS ARE ADVISED, HOWEVER, OSHA REGULATIONS ALSO PERMIT
OTHER TYPES OF SAFETY GLASSES. CONSULT YOUR SAFETY EQUIPMENT
REPRESENTATI VE.
================== Physical/Chemical Properties ==================
Boiling Pt:>101.1C, 214.F
B.P. Text:@ 760.00 MM HG
Vapor Density:>1 (AIR=1)
Spec Gravity:>1 (H*2O=1)
pH:8.9
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:LIGHT ORANGE SEMI-SOLID, WITH MILD SURFACTANT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, STRONG ACIDS.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
VARIOUS HYDROCARBONS.
===================== Ecological Information =====================
Ecological:TOXIC TO FISH.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL OF MATERIAL SHOULD BE DONE IN
ACCORDANCE WITH ALL FEDERAL (40 CFR PART 261), STATE AND LOCAL
ENVIRONMENTAL CONTROL REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:DOT PROPER SHIPPING NAME (49 CFR 172.101): NOT
D.O.T. REGULATED. HAZARD CLASS (DOT, IATA)/HAZARD CLASS (IMO)/ID
NUMBER/PACKING GROUP/ADDITIONAL DESCRIPTION/LABELS
REQUIRED/EMERGENCY RESPONSE GUIDEBOOK NUMBER/1996 NORTH AMERICAN
EMERGENCY RESPONSE GUIDEBOOK NUMBER/EMS NUMBER/MFAG TABLE
NUMBER/REPORTABLE QUANTITY (DOT): NOT APPLICABLE.
===================== Regulatory Information =====================
SARA Title III Information:THIS PRODUCT CONTAINS THE FOLLOWING TOXIC
SUBSTANCES SUBJECT TO THE REPORTING REQUIREMENTS OF SECTION 313 OF
TITLE III OF THE SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT
(EMERGENCY PLANNING AND COMMU NITY RIGHT-TO-KNOW ACT) OF 1986 AND
OF 40 CFR PART 372: TRIETHANOLAMINE, CAS # 102-71-6, 22% BY VOLUME;
OLEIC ACID, CAS # 112-80-1, 27% BY VOLUME.
Federal Regulatory Information:TOXIC SUBSTANCES CONTROL ACT: THE
CHEMICAL SUBSTANCES IN THIS PRODUCT ARE LISTED ON THE TSCA SECTION
8 CHEMICAL SUBSTANCE INVENTORY LIST (40 CFR PART 710).
State Regulatory Information:
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PR-855 PART B
CAGE:DO563
CAGE:92108
CAGE:DO563
============= Composition/Information on Ingredients =============
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
OSHA PEL:0.1 MG/M3 RDUST
ACGIH TLV:0.1 MG/M3 RDUST
Ingred Name:POLYDIMETHYL SILOXANE, HYDROXY TERMINATED
CAS:70131-67-8
Ingred Name:METHYL HYDROGEN POLYSILOXANE
CAS:63148-57-2
Ingred Name:DIMETHYL, METHYL HYDROGEN SILOXANE COPOLYMER
CAS:68037-59-2
Ingred Name:POLYDIMETHYL SILOXANE, DIMETHYL VINYL TERMINATED
CAS:68083-19-2
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EYE/SKIN: TEMPORARY DISCOMFORT.
INHALATION/INGESTION: NONE KNOWN.
Explanation of Carcinogenicity:CRYSTALLINE SILICA QUARTZ: GRP 2A (IARC
VOL7, P341'87); ANTIC CARCIN (NTP 6TH ANN RPT, '91).
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH WITH LUKE WARM WATER FOR AT LEAST 15 MINUTES.
SKIN: WASH WITH SOAP AND WATER. INHALATION: REMOVE FROM EXPOSURE.
SUPPORT BREATHING (GIVE ARTIFICIAL RESPIRATION/OXYGEN) . INGESTION:
CAL L MD IMMEDIATELY .
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE KNOWN.
================== Accidental Release Measures ==================
Spill Release Procedures:COVER WITH ABSORBENT. SCOOP INTO CONTAINERS.
CLEAN-UP RESIDUE WITH 1,1,1-TRICHLOROETHANE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE.
Other Precautions:NONE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:GENERAL VENTILATION.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Spec Gravity:1.03
Solubility in Water:NEGLIGIBLE
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:SILICON DIOXIDE, CARBON DIOXIDE AND
TRACES OF INCOMPLETELY BURNED CARBON PRODUCTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:NOT HAZARDOUS WASTE ACCORDING TO EPA
REGULATIONS. CONSULT STATE REGULATIONS PRIOR TO DISPOSAL OF
SPILLAGE. DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE AND LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
=======================================================
Product ID: 502-194, CARBON, NITROGEN, HYDROGEN, (SUPDAT)
Cage: 94174
=======================================================
Contractor Summary
=======================================================
Cage: 94174
=======================================================
Ingredients
=======================================================
Cas: 7439-89-6
RTECS #: NO4565500
% Wt: 95-99
OSHA PEL: 10 MG/M3 (MFR)
ACGIH TLV: 5 (FUME) (MFR)
------------------------------
Cas: 1309-37-1
RTECS #: NO7400000
OSHA PEL: 10 MG/M3 (FE)
ACGIH TLV: 5 MG/M3 FUME, B2
------------------------------
Cas: 7440-44-0
RTECS #: FF5250100
% Wt: <1
OSHA PEL: 15 MG/M3 TDUST
ACGIH TLV: 2 MG/M3 TDUST
-----------------------------
Cas: 1333-86-4
RTECS #: FF5800000
OSHA PEL: 3.5 MG/M3
ACGIH TLV: 3.5 MG/M3
------------------------------
Cas: 7439-96-5
RTECS #: OO9275000
% Wt: <1.65
OSHA PEL: C 5 MG/M3 DUST
ACGIH TLV: 5 MG/M3 DUST
------------------------------
Cas: 7440-21-3
RTECS #: VW0400000
% Wt: 1.6
OSHA PEL: 15 MG/M3 TDUST
ACGIH TLV: 10 MG/M3 TDUST
------------------------------
Cas: 7704-34-9
RTECS #: WS4250000
% Wt: 0.040
OSHA PEL: 13 MG/3 (MFR)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 7440-31-5
RTECS #: XP7320000
% Wt: 1.0
OSHA PEL: 2 MG/M3
ACGIH TLV: 2 MG/M3
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: YES
OSHA: NO
Effects of Exposure: ACUTE: EYES: CAN CAUSE IRRITATION. SKIN: CAN CAUSE
IRRITATION. INHALATION: CAN IRRITATE THROAT AND MILDLY IRRITATE MUCOUS
MEMBRANES; MAY EXPERIENCE METALLIC TASTE IN MOUTH. INGESTION: NOT AVAILABLE.
A CUTE OVEREXPOSURE: CAN CAUSE METAL FUMEFEVER. CHRONIC OVEREXPOSURE: CAN
CAUSE PULMONARY EFFECTS, (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: CARBON BLACK: IARC MONOGRAPHS, VOL 65, PG 149,
1996: GROUP 2B.
Signs And Symptions Of Overexposure: HLTH HAZ: SIDEROSIS, BRONCHITIS, LACK OF
COORDINATION, OR BENIGN PNEUMOCONIOSIS OF THE LUNGS(STANNOSIS).
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: EYES: FLUSH THOROUGHLY WITH RUNNING WATER TO REMOVE PARTICULATE FOR
AT LEAST 15 MINUTES, OBTAIN MEDICAL ATTENTION. SKIN: REMOVE PARTICLES BY
WASHING THOROUGHLY WITH SOAP AND WATER. SEEK MEDICAL ATTENT ION IF CONDITIONS
PERSISTS. INHALATION:REMOVE TO FRESH AIR; IF CONDITION CONTINUES, CONSULT A
PHYSICIAN. INGESTION: IF SIGNIFICANT AMOUNTS OF METAL ARE INGESTED, CONSULT
PHYSICIAN.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: SMALL/LARGE SPILL: FINE TURNINGS SHOULD BE SWEPT OR
VACUUMED. SCRAP METAL CAN BE RECLAIMED FOR RE-USE.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: USED OR UNUSED PRODUCT SHOULD BE DISPOSED OF IN
ACCORDANCE WITH FEDERAL, STATE OR LOCAL LAWS AND REGULATIONS. DISPOSER MUST
COMPLY WITH FEDERAL, STATE AND LOCAL DISPOSAL OR DISCHARGE LAWS.
Handling And Storage Precautions: KEEP CONTAINER CLOSED. IN WELDING, PRECAUTION
SHOULD BE TAKEN FOR AIRBORNE CONTAMINANTS WHICH MAY ORIGINATE FROM COMPONENTS
OF THE WELDING ROD.
Other Precautions: ARC OR GENERATED SPARK WHEN WELDING OR BURNING COULD BE A
SOURCE OF IGNITION FOR COMBUSTION AND FLAMMABLE MATERIALS. AVOID GENERATION
OF AIRBORNE FUME AND DUST.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: NONE
Lower Limits: NONE
Upper Limits: NONE
Extinguishing Media: DO NOT USE WATER ON MOLTEN METAL. MEDIA SUITABLE FOR
SURROUNDING FIRE (FP N).
Fire Fighting Procedures: USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: STEEL WIRE DOES NOT PRESENT FIRE/EXPLO HAZ UNDER
NORM CNDTNS. FINE METAL PARTICLES SUCH AS PRDCED WHEN SAWING/GRINDING CAN
BURN. HIGH CONCS OF METALLIC (SUPDAT)
=======================================================
Control Measures
=======================================================
Respiratory Protection: APPROPRIATE DUST/FUME/MIST RESPIRATOR SHOULD BE USED TO
AVOID EXCESS INHALATION OF PARTICULATES. IF EXPOSURE LIMITS ARE REACHED OR
EXCEEDED, USE NIOSH APPROVED EQUIPMENT.
Ventilation: AS REQUIRED DEPENDING ON OPERATIONS AND SAFETY CODES.
Other Protective Equipment: ANSI APPRVD EYE WASH & DELUGE SHOWER (FP N). AS
REQUIRED DEPENDING ON OPERATIONS AND SAFETY CODES.
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: MFR TRADE NAME/PART NO: OXYGEN,OR SULFUR IN
STEEL (CALIBRATION SAMPLE). EXPLO HAZ: FINES IN AIR MAY PRESENT EXPLO HAZARD.
MATLS TO AVOID: OF IRON & ALLOYING ELEMENTS.
=======================================================
Physical/Chemical Properties
=======================================================
M.P/F.P Text: 2800F,1538C
Spec Gravity: 7
Evaporation Rate & Reference: NOT KNOWN
Solubility in Water: NOT KNOWN
Appearance and Odor: GREY OR BLACK METAL. NO ODOR.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: REACTS W/STRONG ACIDS TO FORM HYDROGEN GAS. STEEL AT TEMPS
ABOVE MELTING POINT MAY LIBERATE FUME CNTNG OXIDES (SUPDAT)
Hazardous Decomposition Products: METALLIC DUST OR FUMES DURING WELDING,
BURNING, GRINDING AND POSSIBLY MACHINING.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: 502-194, CARBON, NITROGEN, HYDROGEN, (SUPDAT)
Cage: 94174
Company Name: LECO CORPORATION
Street: 3000 LAKEVIEW AVE.
Zipcode: 49085-2396
Label Required IND: Y
Date Of Label Review: 07/28/1998
Status Code: C
Label Date: 07/28/1998
Origination
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE: EYES: CAN CAUSE IRRITATION. SKIN: CAN CAUSE
IRRITATION. INHALATION: CAN IRRITATE THROAT AND MILDLY IRRITATE MUCOUS
MEMBRANES; MAY EXPERIENCE METALLIC TASTE IN MOUTH. INGESTION: NOT AVAILABLE.
A CUTE OVEREXPOSURE: CAN CAUSE METAL FUMEFEVER. CHRONIC OVEREXPOSURE: CANCER
HAZARD. CONTAINS CARBON BLACK WHICH IS LISTED AS AN ANIMAL LUNG CARCINOGEN
(FP N). CAN CAUSE PULMONARY EFFECTS, SIDEROSIS, BR ONCHITIS, LACK OF
COORDINATION, OR BENIGN PNEUMOCONIOSIS OF LUNGS(STANNOSIS)
=======================================================
| 1 | gloves_mandatory |
=======================================================
NIIN: 01-358-5916
Product ID: PRINT CARTRIDGES FOR DESKJET 500C AND (SUPP
Cage: 28480
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 28480
=======================================================
Item Description Information
=======================================================
Item Manager: GSA
Item Name: INK,CARTRIDGE
Unit of Issue: EA
UI Container Qty: 0
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: LD50:(ORAL)>2000 MG/KG (BLUE,(SUPP DATA)
Route Of Entry Inds - Inhalation: NO
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE: SKIN/EYE: ALL INKS NON-IRRITATING. DYES IN INK MAKE
EXPOSURE EASY TO DETECT. SYMPTOMS OF EXPOSURE ARE DESRIBED BELOW. EYE:
CONTACT WITH EYES MAY CAUSE IRRITATION. SKIN: NONE OF THE INKS ARE TOX IC BY
SKIN CONTACT. CONTACT W/SKIN MAY CAUSE IRRITATION. INGEST: INGESTION OF INK
MAY RESULT IN GASTRIC DISTURBANCES.
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: EYE: FLUSH WITH LARGE AMOUNTS OF WATER FOR AT LEAST 15 MIN. SKIN:
WASH AFFECTED AREA WITH SOAP AND WATER. INGEST: DILUTE WITH WATER. GET
MEDICAL ATTENTION. INHAL: REMOVE TO FRESH AIR. SUPPORT BREATHIN G (GIVE
O*2/ARTF RESP)(FP N).
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: USE ABSORBENT TOWEL TO WIPE UP INK. RINSE AREA WITH
DAMP CLOTH TO REMOVE REMAINING TRACES OF INK.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE FEDERAL,
STATE AND LOCAL LAWS.
Handling And Storage Precautions: KEEP OUT OF REACH OF CHILDREN. AVOID CONTACT
BETWEEN THE GOLD CARTRIDGE FACE AND EYES, SKIN AND CLOTHING.
Other Precautions: RAPID REMOVAL OF INK WITH SOAP AND WATER FROM SKIN PREVENTS
IRRITATION AND STAINING.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: >255F,>124C
Extinguishing Media: WATER, DRY CHEMICAL, CARBON DIOXIDE, FOAM.
Fire Fighting Procedures: WEAR NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE
OF CONCERN (FP N).
Ventilation: NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment: NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: MFR TRADE NAME/PART NO: DESKWRITER C, 51625A.
LD50: RED, BLACK & YELLOW INKS)
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: >230F,>110C
Vapor Pres: 15 @ 20C
Vapor Density: 3.0
Spec Gravity: 1.1
Solubility in Water: COMPLETELY MISCIBLE
Appearance and Odor: COLORED LIQUID, PRACTICALLY ODORLESS
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: NONE
Hazardous Decomposition Products: NONE
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
Transportation Information
=======================================================
Trans ID NO: 129061
Product ID: PRINT CARTRIDGES FOR DESKJET 500C AND (SUPP
Review Date: 09/21/1993
Multiple KIT Number: 0
Review IND: Y
Unit Of Issue: EA
Container QTY: 0
Additional Data: NOT REGULATED FOR TRANSPORTATION
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: ZZZ
DOT Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: ZZZ
IMO Proper Shipping Name: NOT REGULATED FOR THIS MODE OF TRANSPORTATION
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: ZZZ
IATA Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: ZZZ
AFI Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
HAZCOM Label
=======================================================
Product ID: PRINT CARTRIDGES FOR DESKJET 500C AND (SUPP
Cage: 28480
Company Name: HEWLETT-PACKARD CO, CORPORATE HQ
Street: 3000 MINUTEMAN RD
Zipcode: 01810-1032
Label Required IND: Y
Date Of Label Review: 02/19/1993
Status Code: C
Label Date: 02/19/1993
Origination Code: G
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: AVOID CONTACT BETWEEN THE GOLD CARTRIDGE FACE AND EYES,
SKIN AND CLOTHING. ACUTE: EYE/SKIN: MAY CAUSE IRRITATION ON CONTACT. INGEST:
MAY RESULT IN GASTRIC DISTURBANCES. CHRONIC: NONE LISTED BY MANUFAC TURER.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:A4418 AMMONIUM SULFATE MOLECULAR BIOLOGY REAGENT
CAGE:21076
CAGE:21076
============= Composition/Information on Ingredients =============
Ingred Name:AMMONIUM SULFATE (2:1), DIAMMONIUM SULFATE; SULFURIC ACID,
DIAMMONIUM SALT
CAS:7783-20-2
RTECS #:BS4500000
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(RAT): 2840 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:HARMFUL IF SWALLOWED, INHALED/ABSORBED
THROUGH THE SKIN. CAUSES EYE & SKIN IRRITATION. MATERIAL IS
IRRITATING TO MUCOUS MEMBRANES & UPPER RESPIRATORY TRACT.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH W/COPIOUS AMOUNTS OF WATER FOR 15
MINS. SKIN: IMMEDIATELY WASH W/SOAP & COPIOUS AMOUNTS OF WATER.
INHALATION: REMOVE TO FRESH AIR. GIVE CPR/OXYGEN IF NECESSARY.
INGESTION: WASH OUT MOUTH W/WATER IF CONSCIOUS. OBTAINMEDICAL
ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER SPRAY, CO2, DRY CHEMICAL POWDER/APPROPRIATE
FOAM
Fire Fighting Procedures:WEAR SELF CONTAINED BREATHING APPARATUS &
PROTECTIVE CLOTHING TO PREVENT CONTACT W/SKIN & EYES.
Unusual Fire/Explosion Hazard:EMITS TOXIC FUMES UNDER FIRE CONDITIONS.
(SEE SUPPLEMENTAL DATA)
================== Accidental Release Measures ==================
FOR WASTE DISPOSAL. AVOID RAISING DUST. VENTILATE AREA & WASH SITE
AFTER MATERIAL PICKUP I S COMPLETE.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS TIGHTLY CLOSED. WEAR
SUITABLE PROTECTIVE CLOTHING.
Other Precautions:AVOID INHALATION & CONTACT W/EYES, SKIN & CLOTHING.
MIXING AMMONIUM SULFATE W/FUSED POTASSIUM NITRITE RESULTS IN A
VIGOROUS REACTION W/FLAMES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE A NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:MECHANICAL EXHAUST
Other Protective Equipment:SAFETY SHOWER, EYE BATH
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
SODIUM HYPOCHLORITE TO A SOLUTION OF ACIDIFIED AMMONIUM SULFATE LED TO
THE FORMATION OF NITROGEN TRICHLORIDE & EXPLODED. CONTACT OF
POTASSIUM/SODIUM-POTASSIUM ALLOY W/A MIXTURE CF AMMONIUM SULFATE &
A MMONIUM NITRATE MAY EXPLODE. HEATING OFPOTASSIUM CHLORATE &
AMMONIUM SULFATE DECOMPOSES W/INCANDESENCE.
================== Physical/Chemical Properties ==================
Decomp Temp:Decomp Text:455F
Spec Gravity:1.769
Appearance and Odor:WHITE CRYSTALS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG BASES, (SEE SUPPLEMENTAL DATA)
Hazardous Decomposition Products:SULFUR OXIDES, AMMONIA, NITROGEN
OXIDES, SULFUR TRIOXIDE (SEE SUPPLEMENTAL DATA)
==================== Disposal Considerations ====================
Waste Disposal Methods:SMALL: ADD TO A LARGE STIRRED EXCESS OF WATER.
ADJUST THE PH TO NEUTRAL, SEPARATE INSOLUBLE SOLIDS/LIQUIDS &
PACKAGE THEM FOR WASTE DISPOSAL. FLUSH AQUEOUS SOLUTION DOWN THE
DRAIN W/PLENTY OF WATER. D ISPOSE OF IAW/LOCAL, STATE & FEDERAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:FIBERGLASS FABRIC, BLACK WEAVEST, 1138
CAGE:IO573
CAGE:0VULI
CAGE:IO573
============= Composition/Information on Ingredients =============
Ingred Name:FIBERGLASS; (CONTINUOUS FILAMENT/FIBERGLASS) MP: 1292F,700C
CAS:65997-17-3
Fraction by Wt: >85.0%
OSHA PEL:5 MG/M3 RESP DUST
ACGIH TLV:10 MG/M3 (<7MICRONS)
Ingred Name:WEAVING SIZE
RTECS #:9999999ZZ
Fraction by Wt: >2.0%
Other REC Limits:N/H
Ingred Name:ACRYLIC LATEX BINDER
Fraction by Wt: 1-14%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PIGMENT
Fraction by Wt: 0.3%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPDAT:CANCER WHEN THE ANIMALS BREATHED LARGE QUANTITIES OF
GLASS FIBERS. ARTIFICIAL IMPLANTATION OR INJECTION (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5:OF FINE GLASS FIBERS INTO THE CHEST, ABDOMINAL CAVITY
OR TRACHEA OF LABORATORY ANIMALS HAS PRODUCED CANCER.
RTECS #:9999999ZZ
Ingred Name:VENT:LOCAL EXHAUST VENTILATION IS NOT FEASIBLE.
RTECS #:9999999ZZ
Ingred Name:OTHER PROT EQUIP:LONG-SLEEVED CLOTHING.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN, EYES, AND RESPIRATORY
IRRITATION. OSHA CLASSIFIES FIBROUS GLASS AS A NUISANCE DUST.
ACUTE:INHAL: MECHANICAL IRRIT OF THE MOUTH, NOSE, & THROAT.
SKIN:TRANSIENT MECHANICAL IRRITATION. EYE:DIRECT C ONTACT WILL
CAUSE MECHANICAL IRRITATION. INGEST:UNLIKELY TO OCCUR. OBSERVE
INDIVIDUAL. IF SYMPTOMS OF (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:GI IRRIT DEVELOP, CONSULT PHYSICIAN.
CHRONIC:INHAL:MANY STUDIES HAVE BEEN CONDUCTED TO DETERM LONG-TERM
EFTS OF FIBROUS GLASS INHAL. ALTHOUGH INCONCLUSIVE, SOME RESEARCH
INDICATED MFG EMPLOYE ES FIRST EMPLOYED MORE THAN 30 YEARS AGO IN
FACTORIES THAT MFRS GLASS WOOL & MINERAL WOOL & MINERAL WOOL HAVE
AN(SUPDAT)
Medical Cond Aggravated by Exposure:ANY CONDITIONS GENERALLY AGGRAVATED
BY MECHANICAL IRRITATANTS IN AIR OR ON SKIN.
======================= First Aid Measures =======================
First Aid:INGEST: CALL MD IMMEDIATELY . EYE: FLUSH WITH WATER FOR AT
LEAST 15 MINUTES; GET MEDICAL ASSISTANCE IF IRITATION PERSISTS.
SKIN: WASH WITH SOAP AND WATER. INHALATION: REMOVE TO FRESH AIR;
DRINK WATER TO CLEAR THROAT AND BLOW NOSE TO EXPEL FIBERS.
===================== Fire Fighting Measures =====================
Flash Point:NON-COMBUSTIBLE
Extinguishing Media:USE THAT WHICH IS APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . THERMAL DECOMPOSITION OF FIBER COATING MAY PRODUCE AN
IRRITATING MIXTURE OF SMOKE AND FUMES.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:PREVENT SPREAD OF FIBERGLASS DUST AND AVOID
DUST GENERATION CONDITIONS. THOSE INVOLVED IN CLEANUP OF
PARTICULATES SHOULD USE APPROPRIATE PERSONAL PROTECTION EQUIPMENT.
VACUUM CLEAN DUSTS. IF SWEEPING IS NECESSARY, USE A DUST
SUPPRESSANT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AND USE IN A MANNER THAT WILL
PREVENT AIRBORNE PARTICULATES IN THE WORKPLACE.
Other Precautions:NONE KNOWN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHERE DUST LEVELS EXCEED THE TLV, USE NIOSH
APPROVED RESPIRATOR TO PROTECT AGAINST NUISANCE DUSTS.
Ventilation:LOCAL EXHAUST:RECOMMENDED FOR PROCESSING MACHINERY WHERE
DUST GENERATION IS APPARENT. MECHANICAL (GENERAL) WHERE (ING 7)
Other Protective Equipment:ANSI APPRVD EMER EYE WASH & DELUGE SHOWER .
BARRIER CREAM. WORK APRONS/SMOCKS. WEAR LOOSE FITTING, (ING 8)
Work Hygienic Practices:WASH THOROUGHLY AFTER WORK. RECOMMEND LAUNDER
WORK CLOTHES SEPARATELY AND WIPE OUT WASHER AT END OF CYCLE.
Supplemental Safety and Health
EFTS OF OVEREXP:INCRD RATE OF LUNG CANCER AS COMPARED TO CERTAIN OTHER
REFERENCE POPULATIONS. FURTHER STUDY IS PLANNED TO IDENTIFY THOSE
FACTORS ASSOCD W/RPTD INCRD RATE. SIMILAR FINDINGS WERE NOT RPT D
REGARDING EMPLOYEES IN TEXTILE MFR PLANTS. ANIMAL STUDIES HAVE NOT
DEMONSTRATED AN INCRD RATE IN LUNG (ING 5)
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:SEE ING 1
Spec Gravity:2.5 (H*2O = 1)
Solubility in Water:INSOLUBLE
Appearance and Odor:WOVEN FABRIC/NO DISCERNABLE ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:NONE KNOWN.
==================== Disposal Considerations ====================
Waste Disposal Methods:IN MOST CASES, MOVE FIBERGLASS SCRAP CAN BE
DISPOSE OF IN A SANITARY LANDFILL IN ACCORDANCE WITH FEDERAL,
STATE, AND LOCAL REGULATIONS. CHECK WITH LOCAL AUTHORITIES OF ANY
QUESTIONS CONCENRING DISPOSA L.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:122 HAI-KN, NICKEL ALLOYS
CAGE:49076
CAGE:49076
============= Composition/Information on Ingredients =============
Ingred Name:ALUMINUM (SARA III)
CAS:7429-90-5
RTECS #:BD0330000
Fraction by Wt: 1%
OSHA PEL:15MG/M3 TDUST;5 FUME
ACGIH TLV:10MG/M3 DUST;5 FUME
Ingred Name:MANGANESE (SARA III)
CAS:7439-96-5
RTECS #:OO9275000
Fraction by Wt: 2%
OSHA PEL:(C) 5 MG/M3 DUST
ACGIH TLV:5 MG/M3 DUST 9293
Ingred Name:NICKEL (SARA III)
CAS:7440-02-0
RTECS #:QR5950000
Fraction by Wt: 95%
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3
Ingred Name:SILICON
CAS:7440-21-3
RTECS #:VW0400000
Fraction by Wt: 2%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:RESP PROT: THE RESPIRATORY PROTECTION SHLD BE USED. USE
ONLY NIOSH/MSHA APPROVED RESPIRATORS I/A/W OSHA 29CFR 1910.134.
RTECS #:9999999ZZ
Ingred Name:VENT: IN INGREDIENT SECTION AND BY USE OF ADEQUATE EXHAUST
VENTILATION.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:UNDER NORM HNDLG/USE, EXPOS TO SOLID,
MASSIVE FORMS OF ALLOY PRESENTS FEW HLTH HAZ. THEY MAY INCL SKIN
IRRIT/ OTHER ALLERGIC RXNS IN SENSITIVE INDIVIDUALS. ACUTE: EXPOS
TO DUST, WELDING FUME & GASES M AY CAUSE NAUS, TIGHTNESS OF CHEST,
FEVER, IRRIT OF EYES/NOSE/ THROAT/SKIN; LOSS OF CONSCIOUSNESS DUE
TO (EFTS OF OVEREXP
Explanation of Carcinogenicity:NICKEL: GROUP 2B (IARC), ANTICIPATED TO
BE A CARCINOGEN (NTP).
Effects of Overexposure:HLTH HAZ: WELDING GASES OR LACK OF O2. CHRONIC:
ADVERSE EFFECTS MAY INCLUDE SKIN SENSITIZATION, NEUROLOGICAL DAMAGE
& RESPIRATORY DISEASES (BRONCHIAL ASTHMA, LUNG FIBROSIS OR
PNEUMOCONIOSIS). RECENT E PIDEMIOLOGICAL STUDIES OF WORKERS MELTING
& WORKING ALLOYS CONTAINING NICKEL HAVE FOUND NO INCREASED RISK OF
CANCER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE FROM EXPOSURE AND OBTAIN PROMPT MEDICAL
ATTENTION. ADMINISTER O2 IF VICTIM IS UNCONSCIOUS. IF NOT
BREATHING, RESUSCITATE IMMEDIATELY. INGEST: CALL MD IMMEDIATELY .
EYES: IMMEDIATEL Y FLUSH W/POTABLE WATER FOR A MINIMUM OF 15
MINUTES, SEEK ASSISTANCE FROM MD . SKIN: FLUSH W/COPIOUS AMOUNTS OF
WATER. CALL MD .
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:MATERIAL IS NONFLAMMABLE; HOWEVER,
WELDING ARCS AND SPARKS CAN IGNITE FLAMMABLE LIQUIDS AND VAPORS AND
COMBUSTIBLE SOLIDS.
================== Accidental Release Measures ==================
Spill Release Procedures:UNDER NORMAL HNDLG/USE, MATL IS NOT VOLAT OR
DUSTY & DOES NOT PRESENT SPILLAGE/LEAKAGE PROBLEMS. NO PROT REQD,
EXCEPT AVOID PRLNG/RPTD DIRECT SKIN CONT IF SENSITIVE TO METALS.
(SUPP DATA)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:MATL IN SOLID FORM DOES NOT REQUIRE
SPECIAL PRECAUTIONS IN HNDLG/STORING. HOWEVER, USE INDUSTRIAL
HYGIENE AIR MONITORING TO ENSURE THAT (SUPP DATA)
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF SOLID METAL ALLOYS ARE CONVERTED IN MFG
(INCLUDING GRINDING, HIGH TEMP CUTTING & WELDING) PROCESSES TO
DUSTS/FUMES/ GASES/MISTS, & VENTILATION IS NOT ADEQUATE TO MAINTAIN
EXPOSURES BELOW LIMITS SPE CIFIED IN INGREDIENTS SECTION, (ING 5)
Ventilation:IF SOLID METAL ALLOYS ARE CONVERTED TO DUSTS/FUMES/ MISTS,
MAINTAIN WORKING ENVIRON BELOW EXPOS LIMITS SPECIFIED (ING 6)
Other Protective Equipment:WHEN CUTTING/GRINDING/WELDING, WEAR FLAME
RETARDANT CLOTHING. SELECT WELDING LENSE SHADE FROM AWS PUBLICATION
F2.2.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
BP: 4982F,2750C +/- 200. HAZ DECOMP PROD: OXIDES OF METALS, CHROMATES,
FLUORIDES & COMPLEX METALLICS. THE GASES MAY INCL CO, OZONE AND
NOX. SPILL PROC: GRINDING OR WELDING OPERATIONS, VACUUM RESIDUE I
NTO SUITABLE CONTRS & DISPOSE. HNDLG/STOR PREC: USE OF THIS MATL
DOES NOT CREATE EXPOS WHICH EXCEED LEVELS SPECIFIED.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:SUPP DATA
Melt/Freeze Pt:M.P/F.P Text:2597F,1425C
Spec Gravity:8.7
Solubility in Water:0
Appearance and Odor:GREY METALLIC (SOLID METALS SHAPED AS WIRE, ROD OR
STRIP). ODORLESS.
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID ACIDS. CONTACT WITH MINERAL ACIDS WILL RELEASE HYDROGEN - A
READILY COMBUSTIBLE GAS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:FUMES/GASES FROM WELDING & HIGH TEMP
CUTTING CNTN CONSTITUENTS DIFFERENT FROM LISTED INGREDIENTS & MAY
INCL (SUPP DATA)
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH EPA OR FEDERAL,
STATE, AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:NEOMYCIN SULFATE, USP
Preparer's Name:PATRICK L. JOHNSON
CAGE:55763
CAGE:55763
============= Composition/Information on Ingredients =============
Ingred Name:NEOMYCIN SULFATE
CAS:1405-10-3
RTECS #:QP4375000
= Wt:100.
===================== Hazards Identification =====================
LD50 LC50 Mixture:NO DATA PROVIDED BY MANUFACTURER
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: MAY CAUSE IRRITATION OF
THE RESPIRATORY TRACT. EYE: MAY CAUSE IRRITATION. SKIN: MAY CAUSE
IRRITATION. INGESTION: MAY IRRITATION OF THE GASTROINTESTINAL
TRACT. CHRONIC: DEAFNESS, KIDNEY DAM AGE, HYPERSENSITIVITY MAY
DEVELOP.
Explanation of Carcinogenicity:NO DATA PROVIDED BY MANUFACTURER
Effects of Overexposure:INGESTION: NAUSEA, VOMITING, DIARRHEA.
Medical Cond Aggravated by Exposure:HYPERSENSITIVITY TO NEOMYCIN.
SHOULD BE USED WITH CAUTION IN PATIENTS RECEIVING OTHER DRUGS WITH
NEUROMUSCULAR BLOCKING ACTIVITY, ANTIOAGULANTS, ANTIEMETICS, AND
OTHER DRUGS WHICH ARE OTOTIC.
======================= First Aid Measures =======================
First Aid:IF HYPERSENSITIVE (ANAPHYLACTIC) REACTIONS DEVELOP, SEEK
IMMEDIATE MEDICAL ASSISTANCE. INHALATION: REMOVE VICTIM FROM
EXPOSURE. IF NOT BREATHING, GIVE ARTIFICIAL RESPIRATION. IF
BREATHING IS DIFFICULT , GIVE OXYGEN. SEEK IMMEDIATE MEDICAL
ASSISTANCE. EYE: FLUSH WITH WATER FOR AT LEAST 15 MINUTES. IF
IRRITATION PERSISTS OR DEVELOPS, SEEK MEDICAL ATTENTION. SKIN:
FLUSH WITH WATER FOR AT LEAST 15 MINU TES. IF IRRITATION PERSISTS
OR DEVELOPS, SEEK MEDICAL ATTENTION. INGESTION: SEEK MEDICAL
ASSISTANCE OR CONTACT A POISON CONTROL CENTER IMMEDIATELY.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER FOG, CARBON DIOXIDE, DRY CHEMICAL
Fire Fighting Procedures:FIREFIGHTERS SHOULD WEAR PROTECTIVE EQUIPMENT
INCLUDING SELF CONTAINED BREATHING APPARATUS
Unusual Fire/Explosion Hazard:AS WITH ANY ORGANIC COMPOUND, THIS
MATERIAL MAY PRESENT AN EXPLOSION HAZARD AS A DUST AND MAY PRODUCE
TOXIC FUMES IF HEATED TO DECOMPOSITION.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR ALL PROTECTIVE EQUIPMENT INCLUDING: DUST
PLACE IN A TIGHT CONTAINER FOR DISPOSAL. WASH ANY EXPOSED SKIN
AREAS THOROUGHLY AFTER HANDLING. WASH CONTAMINATED CLOTHING AND
PROTECTIVE EQUIPMENT BEFORE REUSE.
Neutralizing Agent:NO DATA PROVIDED BY MANUFACTURER
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLING: AVOID CONTACT WITH EYES,
SKIN OR CLOTHING. AVOID BREATHING DUST. WASH ANY EXPOSED SKIN AREAS
THOROUGHLY AFTER HANDLING AND WASH ANY CONTAMINATED CLOTHING BEFORE
REUSE. STORAGE: STORE IN A TI GHT, LIGHT RESISTANT CONTAINER IN A
COOL, DRY LOCATION. AVOID EXPOSURE TO MOISTURE
Other Precautions:WASH THOROUGHLY AFTER HANDLING AND WASH ANY
CONTAMINATED CLOTHING BEFORE REUSE. DO NOT EAT, DRINK OR SMOKE NEAR
THIS MATERIAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED DUST RESPIRATOR
Ventilation:LOCAL OR MECHANICAL EXHAUST RECOMMENDED TO MIMIMIZE
AIRBORNE LEVELS IF DUST IS GENERATED.
WEARING CONTACT LENSES
Other Protective Equipment:APPROVED LABORATORY APPAREL
Work Hygienic Practices:WASH THOROUGHLY AFTERN HANDLING AND WASH ANY
CONTAMINATED CLOTHING BEFORE REUSE. DO NOT EAT, DRINK OR SMIKE NEAR
THIS MATERIAL.
Supplemental Safety and Health
NO DATA PROVIDED BY MANUFACTURER
================== Physical/Chemical Properties ==================
HCC:T6
Solubility in Water:FREELY SOLUBLE
Appearance and Odor:WHITE TO SLIGHTLY YELLOW, HYGROSCOPIC POWDER,
ODORLESS TO PRACTICALLY ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
INCOMPATIBLE IN SOLUTION WITH SOME ANONIC SUBSTANCES, WITH WHICH IT MAY
FORM A PROCIPITATE.
Stability Condition to Avoid:AVOID EXPOSURE TO HEAT, LIGHT AND MOISTURE
Hazardous Decomposition Products:NONE KNOWN
Conditions to Avoid Polymerization:MAY OCCUR. NO OTHER INFORMATION
PROVIDED BY MANUFACTURER.
=================== Toxicological Information===================
Toxicological Information:NEOMYCIN SULFATE HAS THE MOST POTENT
OTOTOXIC, NEPHROTOXIC AND NEUROMUSCUALR BLOCKING POTENTIALS IN THE
COMMERCIALLY AVAILABLE AMINOGLYCOSIDE ANTIBIOTICS. IT IS ALSO ONE
OF THE MOST STRONGLY TISSUE BO UND. OTOTOXICITY, NEPHROTOXICITY,
NEUROTOXICITY OR A COMBINATION OF THOSE TOXIC REACTIONS HAS
OCCURRED FOLLOWING: THE IRRIGATION OF WOUNDS, DECUBITUS ULCERS,
JOINTS AND FRACTURES; INTRAPERITONEAL, INT RAPLEURAL, MEDIASTINAL
AND RECTAL AND COLONIC LAVAGE; INFUSION INTO AN EMPYEMA CAVITY; USE
IN SINUSES AND DIALYSIS FLUIDS; LOCAL APPLICATIONS TO PREVENT BURN
WOUND SEPSIS, CUTANEOUS APPLICATIONS OF IM PREGNATED SKIN GRAFTS.
===================== Ecological Information =====================
Ecological:NO DATA PROVIDED BY MANUFACTURER
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE OR LANDFILL ACCORDING TO ALL LOCAL,
STATE, FEDERAL AND ENVIRONMENTAL REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:NO DATA PROVIDED BY MANUFACTURER
===================== Regulatory Information =====================
SARA Title III Information:NO DATA PROVIDED BY MANUFACTURER
Federal Regulatory Information:NO DATA PROVIDED BY MANUFACTURER
State Regulatory Information:NO DATA PROVIDED BY MANUFACTURER
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:BOILED LINSEED OIL
CAGE:0A9L8
CAGE:0A9L8
============= Composition/Information on Ingredients =============
Ingred Name:BOILED LINSEED OIL IS NOT A HAZARDOUS MATERIAL ACCORDING TO
29 CFR 1910.1200
CAS:8001-26-1
RTECS #:OI9690000
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: IRRIT, DERMATITIS. INGEST: IRRIT
STOMACH & INTESTINES. ASPIRATED INTO LUNGS RESULTING IN CHEMCIAL
PNEUMONITIS.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH W/WATER FOR 15 MINUTES. SKIN: REMOVE CONTAM
CLOTHES & SHOES. WASH W/SOAP & WATER. INHAL: REMOVE TO FRESH AIR.
GET MEDICAL ATTENTION AT ONCE. INGEST: DONT INDUCE VOMIT. KEEP WARM
& QUIET. GE T MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:200F,93C
Extinguishing Media:WATER, CARBON DIOXIDE, FOAM EXTINGUISHERS FOR CLASS
III B LIQUID FIRES.
Fire Fighting Procedures:USE SCBA. SHUT OFF SOURCE. WATER FOG/SPRAY TO
COOL CONTAINERS OR EQUIPMENT. DONT SPRAY WATER DIRECTLY ON FIRE.
PRODUCT WILL FLOAT & REIGNITED ON SURFACE.
Unusual Fire/Explosion Hazard:BOILED LINSEED OIL WILL OXIDIZE & CAUSE
SPONTANEOUS COMBUSTION. AVOID SPONTANEOUS COMBUSTION OF CONTAM
RAGS/IGNITABLE ABSORBENT MATERIAL, BY IMMERSING IN WATER.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE IGNIT SOURCES. VENT AREA. USE
SUPPLIED-AIR MASK FOR LARGE SPILLS OR IN CONFINED AREAS. CONTAIN
SPILL. REMOVE W/INERT ABSORBENT. AVOID ALLOWING PRODUCT TO ENTER
STREAMS OR SEWERS.
======================Handling and Storage ======================
Handling and Storage Precautions:TRANSPORT, HANDLE, STORE IN ACCORDANCE
W/29 CFR (1910.106) & DOT REGULATIONS. GROUND & ELECTRICALLY
INTERCONNECT CONTAINERS FOR TRANSFER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESPIRATORY PROTECTION MAY BE REQUIRED IF
MATERIAL IS USED IN POORLY VENTILATED AREAS OR IF MATERIAL IS
SPRAYED OR HEATED.
Ventilation:GENERAL VENTILATION IS RECOMMENDED. LOCAL VENTILATION MAY
BE REQUIRED IF MATERIAL IS SPRAYED OR HEATED.
Other Protective Equipment:PROTECTIVE CLOTHES SUCH AS UNIFORMS. EYE
WASH STATION AVAILABLE.
Work Hygienic Practices:DONT WEAR CONTACT LENSES. FOLLOW SAFE WORK
PRACTICES. WASH HANDS PRIOR TO EATING OR SMOKING.
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
Spec Gravity:0.93 @ 77F
pH:NA
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR, LOW ODOR.
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE AND
POSSIBLY ACROLEIN.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE OR PLACE IN RCRA PERMITTED WASTE
MANAGEMENT FACILITY IN ACCORDANCE W/LOCAL, STATE & FEDERAL
REGULATIONS.
======================================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:R3510 COPPER CHEMETS, VACUETTES AND VACU-VI
Preparer's Name:HENRY B. CASTANEDA
CAGE:7K791
CAGE:7K791
============= Composition/Information on Ingredients =============
Ingred Name:BATHOCUPROIN
CAS:4733-39-5
Fraction by Wt: 0.1%
Other REC Limits:NONE SPECIFIED
Ingred Name:OXALIC ACID
CAS:144-62-7
RTECS #:RO2450000
Fraction by Wt: 0.5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:1 MG/M3/2 STEL
ACGIH TLV:1 MG/M3/2 STEL; 9192
Ingred Name:SODIUM BISULFITE (SASA III)
CAS:7631-90-5
RTECS #:VZ2000000
Fraction by Wt: 0.5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ACETONE (SARA III)
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: <1.0%
Other REC Limits:NONE SPECIFIED
OSHA PEL:1000PPM
ACGIH TLV:750PPM/1000STEL;9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ACETIC ACID (SARA III)
CAS:64-19-7
RTECS #:AF1225000
Fraction by Wt: 15%
Other REC Limits:NONE SPECIFIED
OSHA PEL:10 PPM
ACGIH TLV:10 PPM/15 STEL; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:AMMONIUM HYDROXIDE(SARA III)
CAS:1336-21-6
RTECS #:BQ9625000
Fraction by Wt: 20%
Other REC Limits:NONE SPECIFIED
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: >62%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SEVEERE EYE, MUCOUS MEMBRANE ANDSKIN
IRRRITANT.
Explanation of Carcinogenicity:NONE OF THE COMPOUNDS IN THIS PRODUCT IS
LISTED BY IARC, NTP, OR OSHA AS A CARCINOGEN.
Effects of Overexposure:EYE:MAY CAUSE CONJUNCTIVITIS SKIN:MAY CAUSE
SENSITIZATION DERMATITIS. INGESTION:BURNING OF MOUTH AND THROAT.
INHALED:NO INFORMATION GIVEN ON MSDS BY SUPPLIER.
Medical Cond Aggravated by Exposure:NO INFORMATION GIVEN ON MSDS BY
SUPPLIER
======================= First Aid Measures =======================
First Aid:EYE:FLUSH W/WATER 15 MIN, HOLD LIDS OPEN. SKIN:WASH WITH
SOAP & WATER. REMOVE CONTAMINATED CLOTHING AND LAUNDER BEFORE
REUSE. INHALED:NO INFORMATION GIVEN ON MSDS BY SUPPLIER.
INGESTED:DO NOT INDUCE VOMITING. GIVE 2 LARGE GLASSES OF MILKOR
WATER AND GET IMMEDIATE MEDICAL CARE. GIVE NOTHING BY MOUTH IF
UNCONSCIOUS. IF IRRITATION PERSISTS OR IS SEVERE,SEE A DOCTOR.
===================== Fire Fighting Measures =====================
Flash Point:104F,40C
Lower Limits:5.4
Upper Limits:16
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED
CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:SHUT OFF IGNITION SOURCES. DO NOT TOUCH
SPILLED MATERIAL. TAKE UP WITH SAND ORT OTHER ABSORBENT MATERIAL
AND PLACE IN SMALL CONTAINERS FOR DISPOSAL.
Neutralizing Agent:NO INFORMATION GIVEN ON MSDS BY SUPPLIER
======================Handling and Storage ======================
Handling and Storage Precautions:NO INFORMATION GIVEN ON MSDS BY
SUPPLIER
Other Precautions:NO INFORMATION GIVEN ON MSDS BY SUPPLIER
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NO INFORMATION GIVEN ON MSDS BY SUPPLIER
Ventilation:LOCAL EXHAUST
Other Protective Equipment:IMPERVIOUS CLOTHING
Work Hygienic Practices:HMIS: USE GOOD CHEMICAL HYGIENE PRACTICE. AVOID
UNNECESSARY CONTACT. WASH THOROUGHLY BEFORE EATING OR DRINKING.
Supplemental Safety and Health
MSDS WAS SUPPLIED BY NAVY (FOCAL POINT N). NAVY IDENTIFIED NSN. NOTE:
CHEMETRICS SUPPLIED THE MSDS'S FOR GLACIAL ACETIC ACID(P/N IND A)
AND AMMONIUM HYDROXIDE (P/N IND B). HMIS IS PASSING THESE ALONG AS
PRESENTED BY THE MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:244F,118C
Melt/Freeze Pt:M.P/F.P Text:62.0F,16.7C
Vapor Pres:11 MM
Spec Gravity:1.04
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS LIQUID, SHARP PUNGENT ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES AND OTHER SOURCES
OF IGNITION
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE I/A/W ALL FEDERAL, STATE AND LOCAL
REGULATIONS. MANUFACTURER MAKES NO SUGGESTIONS AS TO METHOD OF
DISPOSAL.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:DI(2-ETHYL HEXYL)PHTHALATE FOR CAPACITOR 05
CAGE:ARIST
CAGE:ARIST
CAGE:0TEN7
CAGE:66097
============= Composition/Information on Ingredients =============
Ingred Name:DI-SEC-OCTYL PHTHALATE (DI-2-ETHYLHEXYL-PHTHALATE)(SARA
III)
CAS:117-81-7
RTECS #:TI0350000
Fraction by Wt: 100%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3/10 STEL
ACGIH TLV:5 MG/M3; 9293
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 ORAL RAT=30,600MG/KG
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHAL:HAZARD UNLIKELY UNLESS HEATED OR
MISTED,CAUSING IRRITATION TO THE MUCOUS MEMBRANES AND UPPER
RESPIRATORY TRACT.SKIN:EXCESSIVE CONTACT MAY PRODUCE
IRRITATION,SENSITIZATION,ALLERGIC DERMATITIS.EYE S:LIQUID OR MIST
MAY PRODUCE IRRITATION.INGEST:GI DISTIRBANCES.CHRONIC:DEHP HAS BEEN
SHOWN TO CAUSE LIVER CANCER.
Explanation of Carcinogenicity:DIETHYLHEXYL PHTHALATE IS
CARCINOGEN(IARC,1987;NTP,1985).POSSIBLE LIVER CANCE AND TERATOGENIC
EFFECTOR.
Effects of Overexposure:INGEST:NAUSEA,VOMITING,DIARRHEA.
Medical Cond Aggravated by Exposure:PERSON WITH CHRONIC RESPIRATORY
DISORDERS(ASTHMA,CHRONIC BRONCHITIS,EMPHYSEMA) MAY BE ADVERSELY
AFFECTED BY FUMES OR AIRBORNE PARTICULATES.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE FROM EXPOSURE.GIVE OXYGEN OR ARTIFICIAL
RESPIRATION IF NEEDED.CALL PHYSICIAN.SKIN:REMOVE CONTAMINATED
CLOTHING;WASH WITH SOAP AND WATER;CALL PHYSICIAN.EYES:FLUSH WITH
LUKEWARM WATER FOR 1 5 MINUTES.CALL PHYSICIAN.INGEST:GIVE 1-2
GLASSES OF WATER OR MILK;INDUCE VOMITING(FINGER DOWN THROAT);CALL
PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:420F,216C
Autoignition Temp:Autoignition Temp Text:474F
Lower Limits:0.3
Extinguishing Media:WATER FOG,FOAM,CARBON DIOXIDE,DRY CHEMICAL.WATER OR
FOAM MAY CAUSE FROTHING.
Fire Fighting Procedures:USE A SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE EQUIPMENT.COOL FIRE EXPOSED CONTAINERS WITH WATER
SPRAY.
Unusual Fire/Explosion Hazard:PRODUCT WILL RELEASE TOXIC FUMES.
================== Accidental Release Measures ==================
Spill Release Procedures:AVOID BREATHING FUMES WHEN THIS MATERIEL IS
HOT.REMOVE SOURCES OF IGNITION.COVER WITH VERMICULITE;SWEEP
UP;PLACE IN LABELED DRUM FOR DISPOSAL.DEHP IS A CERCLA HAZARDOUS
MATERIEL;REPORT SPILLS TO 800-4 24-8802(NATL RESP.CTR)
Neutralizing Agent:NONE
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A WELL-VENTILATED AREA AWAY
FROM OXIDIZING AGENTS,HEAT,SOURCES OF IGNITION.AVOID CONTACT WITH
LIQUID,MISTS AND VAPORS.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE A NIOSH/MSHA APPROVED RESPIRATOR FOR ORGANIC
VAPORS.
Ventilation:LOCAL VENTILATION AT THE WORK SITE;ADDITIONALLY USE GENERAL
DILUTION VENTILATION.
Other Protective Equipment:EYE WASH STATION,QUICK DRENCH SHOWER.
Work Hygienic Practices:WASH HANDS.SEPERATE WORK CLOTHES FROM STREET
CLOTHES.LAUNDER WORK CLOTHES BEFORE REUSE.KEEP FOOD OUT OF THE WORK
AREA.
Supplemental Safety and Health
ITEM IS A CAPACITOR. LD50 DERMAL(RABBIT)=25G/KG FOR DEHP.
================== Physical/Chemical Properties ==================
HCC:T6
Boiling Pt:B.P. Text:446F,230C
Vapor Pres:NEGLIGIBLE
Vapor Density:13.5
Spec Gravity:0.982
Solubility in Water:NEGLIGIBLE .02%
Appearance and Odor:LIQUID;CLEAR;MILD ODOR
Percent Volatiles by Volume:NEGLIG
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NITRATE,STRING OXIDIZERS,STRONG ACIDS,STRONG ALKALI
Stability Condition to Avoid:MANUFACTURER STATES NONE KNOWN.
Hazardous Decomposition Products:CARBON MONOXIDE,CARBON DIOXIDE,ORGANIC
ACID.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL,STATE AND
LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:RONEX EXTRA DUTY MOLY, 415195-05195
CAGE:29667
CAGE:29667
CAGE:29700
============= Composition/Information on Ingredients =============
Ingred Name:ING 12:IF OVERCOME BY VAP FROM HOT PROD,IMMED REMOVE FROM
EXPOS & CALL PHYS.IF BRTHG IS IRREG/HAS STOPPED,START (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13:RESUSCITATION; ADMIN OXYGEN,IF AVAIL.IF OVEREXPOS TO
OIL MIST, REMOVE FROM FURTHER EXPOS UNTIL EXCESSIVE (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14: OIL MIST CONDITION SUBSIDES. INGESTION: DO NOT
INDUCE VOMITING; CALL A PHYSICIAN IMMEDIATELY.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC: OF IGNIT. DO NOT REUSE LINERS FOR ANY PURPOSE
WHATSOEVER. LINERS SHOULD BE EMPTIED OF CONTENTS TO (ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16: MAX EXTENT PRACTICAL, THEN SEGREGATED FROM LINERS
CONTAINING OTHER PRODS. DISP OF "EMPTY" LINERS IN AN (ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17:ENVIRON SAFE MANNER & I/A/W GOVT REGS. DO NOT
ATTEMPT TO CLEAN SINCE RESIDUE IS DFCLT TO REMOVE. "EMPTY" (ING 19)
RTECS #:9999999ZZ
Ingred Name:ING 18:DRUMS SHOULD BE COMPLETELY DRAINED, PROPERLY BUNGED
& PROMPTLY RETURNED TO DRUM RECONDITIONER. ALL OTHER (ING 20)
RTECS #:9999999ZZ
Ingred Name:ING 19: CNTNRS SHOULD BE DISP OF IN AN ENVIRON SAFE MANNER
& I/A/W GOVT REGS. FOR WORK ON TANKS REFER TO OSHA (ING 21)
RTECS #:9999999ZZ
Ingred Name:ING 20: REGS, ANSI Z49.1, & OTHER GOVT & INDUSTRIAL
REFERENCES PERTAINING TO CLEANING, REPAIRING, WELDING/OTHER (ING
22)
RTECS #:9999999ZZ
Ingred Name:ING 21: CONTEMPLATED OPERATIONS.
RTECS #:9999999ZZ
Ingred Name:DISTILLATES (PETROLEUM), SOLVENT-REFINED HEAVY NAPHTHENIC
(CONSISTING OF CAS NUMBERS 64742-63-8, 64742-62-7, (ING 2)
CAS:64741-96-4
RTECS #:PY8040000
Fraction by Wt: >91%
Ingred Name:ING 1: 64742-65-0, AND 64742-54-7).
RTECS #:9999999ZZ
Ingred Name:LITHIUM COMPLEX SOAP THICKENER
Ingred Name:MOLYBDENUM SULFIDE; (MOLYBDENUM DISULFIDE)
CAS:1317-33-5
RTECS #:QA4697000
Fraction by Wt: 3%
OSHA PEL:10 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:PROPRIETARY ADDITIVES
Fraction by Wt: <6%
Ingred Name:SUPP DATA: BREAKS & MEALS,& AT END OF WORK PERIOD. PROD IS
READILY REMOVED FROM SKIN BY WATERLESS HAND CLEANERS (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6: FOLLOWED BY WASHING THOROUGHLY WITH SOAP AND WATER.
RTECS #:9999999ZZ
Ingred Name:FIRE FIGHT PROC: VAPS & TO PROVIDE PROT FOR MEN ATTEMPTING
TO STOP LEAK. WATER SPRAY MAY BE USED TO FLUSH SPILLS (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8: AWAY FROM EXPOSURES. MINIMIZE BREATHING OF GASES,
VAPOR, FUMES OR DECOMPOSITION PRODUCTS.
RTECS #:9999999ZZ
Ingred Name:EXPLO HAZ: SPARKS, STATIC ELECTRICITY OR OTHER SOURCES OF
IGNITION; THEY MAY EXPLODE AND CAUSE INJURY OR DEATH.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC:INJECTION MAY BE MIN/ABSENT, EARLY SURGICAL
TREATMENT W/IN FIRST FEW HRS MAY SIGNIFICANTLY REDUCE(ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11:ULTIMATE EXTENT OF INJ. INHAL: VAP PRESS IS VERY
LOW. VAP INHAL UNDER AMBIENT CNDTNS IS NORM NOT PROBLEM.(ING 13)
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50: (ORAL,RAT) >5 G/KG.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:PROLOGNED OR REPEATED SKIN CONTACT
WITH PRODUCT TENDS TO REMOVE SKIN OILS, POSSIBLY LEADING TO
IRRITATION AND DERMATITIS; HOWEVER, BASED ON HUMAN EXPERIENCE AND
AVAILABLE TOXICOLOGICAL DATA, PRODUCT I S JUDGED TO BE NEITHER
"CORROSIVE" NOR AN "IRRIT" BY OSHA CRITERIA. PRODUCT CONTACTING
EYES MAY CAUSE (EFTS OF OVEREXP)
Explanation of Carcinogenicity:DISTILLATES (PETROLEUM), SOLVENT-DEWAXED
HEAVY NAPHTHENIC: GROUP 1 (IARC).
Effects of Overexposure:HLTH HAZ: EYE IRRITATION. PRODUCT HAS LOW ORDER
OF ACUTE ORAL AND DERMAL TOXICITY, BUT MINUTE AMOUNTS ASPIRATED
INTO LUNGS DURING INGESTION OR VOMITING MAY CAUSE MILD TO SEVERE
PULMONARY INJURY AND PO SSIBLY DEATH.
Medical Cond Aggravated by Exposure:NONE RECOGNIZED.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH W/CLEAR WATER FOR AT LST 15 MIN/UNTIL IRRIT
SUBSIDES. IF IRRIT PERSISTS, CALL PHYS. SKIN: REMOVE ANY CONTAM
CLTHG & WASH SKIN W/SOAP & WATER. LAUNDER/DRY-CLEAN CLTHG BEFORE
REUSE. IF PROD IS INJECTED INTO/UNDER SKIN/INTO ANY PARTOF BODY,
REGARDLESS OF APPEARANCE OF WOUND/ITS SIZE, INDIV SHOULD BE
EVALUATED IMMED BY PHYS AS SURGICAL EMERG.EVEN THOUGH INITIAL SYMP
FROM HIGH PRESS (ING 11)
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:430F,221C
Lower Limits:0.9%
Upper Limits:7%
Extinguishing Media:FOAM, WATER SPRAY (FOG), DRY CHEMICAL, CARBON
DIOXIDE AND VAPORIZING LIQUID TYPE EXTINGUISHING AGENTS.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT
EQUIP.USE WATER TO KEEP FIRE-EXPOS CNTNRS COOL.IF LEAK/SPILL HAS
NOT IGNITED,USE WATER SPRAY TO DISPERSE (ING 8)
Unusual Fire/Explosion Hazard:"EMPTY" CNTNRS RETAIN RESIDUE (LIQ &/OR
VAP) & CAN BE DANGEROUS. DO NOT PRESS,CUT, WELD,BRAZE,
SOLDER,DRILL, GRIND/EXPOS SUCH CNTNRS TO HEAT,FLAME, (ING 10)
================== Accidental Release Measures ==================
Spill Release Procedures:RECOVER FREE PROD. ADD SAND, EARTH/OTHER
SUITABLE ABSORB TO SPILL AREA. MIN SKIN CONT. KEEP PROD OUT OF
SEWERS & WATERCOURSES BY DIKING/IMPOUNDING. ADVISE AUTH IF PROD HAS
ENTERED/MAY ENTER SEWERS, WA TERCOURSES/EXTENSIVE LAND AREAS.
ASSURE(SUPDAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CNTNRS CLSD WHEN NOT IN USE.DO
NOT STORE NEAR HEAT, SPARKS, FLAME/STRONG OXIDANTS. IN ORDER TO
PVNT FIRE/EXPLO HAZ, USE APPROPRIATE EQUIPMENT.
Other Precautions:USE PROD W/CAUTION AROUND HEAT, SPARKS,PILOT LIGHTS,
STATIC ELEC,& OPEN FLAME."EMPTY" DRUM LINERS RETAIN RESIDUE
(SOLID,LIQ &/OR VAP)THAT WILL BURN & CAN BE DANGEROUS. KEEP AWAY
FROM HEAT,SPARKS, FLAM ES, STATIC ELEC/OTHER SOURCES (ING 16)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED SUPPLIED-AIR RESPIRATORY
PROTECTION IN CONFINED OR ENCLOSED SPACES, IF NEEDED.
Ventilation:USE LOC EXHST TO CAPTURE VAP, MISTS/FUMES, IF NEC.PROVIDE
VENT SUFF TO PVNT EXCEEDING RECOM EXPOS LIMIT/BUILDUP (SUPDAT)
Other Protective Equipment:USE CHEMICAL-RESISTANT APRON/OTHER
IMPERVIOUS CLTHG, IF NEEDED, TO AVOID CONTAM REG CLTHG,WHICH COULD
RSLT IN (SUPDAT)
Work Hygienic Practices:MIN BRTHG VAP, MIST/FUMES. AVOID PRLNGD/RPTD
CONT W/SKIN.REMOVE CONTAMD CLTHG; LAUNDER/DRY-CLEAN BEFORE RE-USE.
(SUPDAT)
Supplemental Safety and Health
SPEC GRAV: (15.6 C/15.6C). SPILL PROC: CONFORMITY W/APPLIC GOVT REGS.
VENT: OF EXPLO CONC OF VAP IN AIR.NO SMOKING, FLAME/OTHER IGNIT
SOURCES. OTHER PROT EQUIP: PRLNGD/RPTD SKIN CONT. HYGIENE PRACT: R
EMOVE CONTAMD SHOES & THORO CLEAN BEFORE RE-USE; DISCARD IF
OIL-SOAKED. CLEANSE SKIN THORO AFTER CONT, BEFORE (ING 6)
================== Physical/Chemical Properties ==================
HCC:V6
Boiling Pt:B.P. Text:590F,310C
Vapor Pres:<0.01 @20C
Vapor Density:>5
Spec Gravity:0.93 (SUPDAT)
pH:NEUT
Evaporation Rate & Reference:<0.01 (N-BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE; <0.1%
Appearance and Odor:SMOOTH PURPLE GREASE, MILD, BLAND ODOR.
Percent Volatiles by Volume:NEGLIG
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDANTS SUCH AS LIQUID CHLORINE, CONCENTRATED OXYGEN, SODIUM
HYPOCHLORITE, CALCIUM HYPOCHLORITE, ETC.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:FUMES, SMOKE, CARBON MONOXIDE, METAL
OXIDES, ALDEHYDES AND OTHER DECOMPOSITION PRODUCTS, IN CASE OF
INCOMPLETE COMBUST.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE AND
LOCAL REGULATIONS .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:BFW-4G CORROSION & SCALE INHIBITOR
CAGE:13091
CAGE:13091
============= Composition/Information on Ingredients =============
Ingred Name:POTASSIUM HYDROXIDE (SARA III)
CAS:1310-58-3
RTECS #:TT2100000
Fraction by Wt: 1-10%
Other REC Limits:2 MG/CUM (CEILING)
OSHA PEL:C, 2 MG/M3
ACGIH TLV:C 2 MG/M3; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:2-DIETHYLAMINOETHANOL
CAS:100-37-8
RTECS #:KK5075000
Fraction by Wt: 1%
OSHA PEL:S, 10 PPM
ACGIH TLV:S, 10 PPM; 9192
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES/INGESTION: CORROSIVE & BURNS.
SKIN: IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES/INGESTION: CORROSIVE & BURNS. SKIN:
IRRITATION.
======================= First Aid Measures =======================
First Aid:EYES/SKIN: FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MINS.
INGESTION: DRINK SEVERAL GLASSES OF MILK/WATER. DON'T INDUCE
VOMITING. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:AS FOR SURROUNDING FIRE. PRODUCT WILL NOT BURN.
Unusual Fire/Explosion Hazard:AS ANY ALKALI CONTAINING SOLUTION, CAN
REACT W/ALUMINUM, GENERATING HYDROGEN WHICH IS FLAMMABLE &/OR
EXPLOSIVE.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL SPILLS: FLUSH DOWN DRAIN W/WATER. LARGE
SPILLS: DIKE TO PREVENT RUNOFF. RECLAIM ALL POSSIBLE. ABSORB
W/INERT MATERIAL & PLACE IN SUITABLE CONTAINERS. FLUSH RESIDUE
W/PLENTY OF WATER. WEAR PROPER EQUIPMENT.
Neutralizing Agent:DILUTE ACID
======================Handling and Storage ======================
Handling and Storage Precautions:OBSERVE NORMAL HANDLING & STORAGE
PROCEDURES. STORE ONLY IN ORIGINAL CONTAINER & KEEP CLOSED WHEN NOT
IN USE. HANDLE AS ANY ALKALINE MATERIAL.
Other Precautions:AVOID CONTACT W/EYES OR SKIN.
============= Exposure Controls/Personal Protection =============
Ventilation:NOT REQUIRED
Other Protective Equipment:AS REQUIRED.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F
Vapor Pres:AS WATER
Vapor Density:AS WATER
Spec Gravity:1.15-1.19
pH:13.25
Evaporation Rate & Reference:AS WATER
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR DARK BROWN LIQUID W/MILD ODOR
Percent Volatiles by Volume:79%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS, ALUMINUM
Hazardous Decomposition Products:HYDROGEN
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE MAY BE DILUTED & NEUTRALIZED VERY
CAREFULLY W/DILUTE ACID IN ACCORDANCE W/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:JTG05197 O/S3268 GREEN OFFSET AGRITEK
CAGE:GO307
CAGE:GO307
CAGE:FLIN1
============= Composition/Information on Ingredients =============
Ingred Name:PETROLEUM DISTILLATE - STREIGHT RUN MIDDLE
CAS:64741-89-5
RTECS #:PY8041500
OSHA PEL:5 MG/CUM
ACGIH TLV:5 MG/CUM
Ingred Name:PIGMENT
Other REC Limits:10 MG/CUM (DUST)
Ingred Name:NUISANCE DUST
OSHA PEL:5 MG/CUM (DUST)
ACGIH TLV:5 MG/CUM (DUST)
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION. INHALATION:
RESPIRATORY TRACT IRRIATION, LUNG INFLAMMATION.
Explanation of Carcinogenicity:SEE INGREDIENTS
Effects of Overexposure:INHALATION: SHORTNESS OF BREATH, COUGH.
======================= First Aid Measures =======================
First Aid:SKIN: WASH W/SOAP & WATER. EYES: FLUSH W/WATER FOR 15 MINS.
INGESTION: DON'T INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Flash Point:220F
Lower Limits:1.1%
Extinguishing Media:FOAM, CO2, DRY CHEMICAL
Fire Fighting Procedures:WEAR SCBA. USE WATER FOG TO COOL CONTAINERS.
WEAR PROTECTIVE CLOTHING & FIGHT FIRE FROM SAFE DISTANCE.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB OR CONTAIN W/SAND OR OTHER ABSORBENT
MATERIAL. WEAR APPROPRIATE EQUIPMENT.
======================Handling and Storage ======================
Handling and Storage Precautions:OVERHEATING MAY CAUSE RUPTURE. STORE
IN COVERED AREA. PROTECT CONTAINER FROM FREEZING.
Other Precautions:55 GALLON CONTAINERS SHOULD BE MOVED W/APPROPRIATE
MATERIAL HANDLING EQUIPMENT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:MSHA/NIOSH APPROVED RESPIRATOR CAPABLE OF
REMOVING VAPORS. A NEGATIVE PRESSURE DEMAND RESPIRATOR WILL SUFFICE
IN ROUTING OPERATIONS.
Ventilation:ADEQUATE EXHAUST AT POINT OF GENERATION TO MAINTAIN
EMPLOYEES BREATHING ZONE AIR BELOW EXPOSURE LIMITS.
Work Hygienic Practices:INGESTION MAY BE POSSIBLE IF MATERIAL IS NOT
THOROUGHLY REMOVED FROM HANDS PRIOR TO EATING.
Supplemental Safety and Health
EXCESSIVE CONCENTRATIONS OF NUISANCE DUSTS IN THE WORKROOM MAY
SERIOUSLY REDUCE VISIBLITY, CAUSE UNPLEASNAT DEPOSITS IN THE NASAL
PASSAGES, EYES, & EARS OR CAUSE INJURY TO THE SKIN DUE TO THE
CONSTANT CLEANSING NECESSARY FOR REMOVAL. NUISANCE DUSTS IN THIS
CASE REFERS TO THE INK/COATING WHEN DRY.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:220-520F
Vapor Pres:<0.1
Vapor Density:>1
Spec Gravity:>1
Evaporation Rate & Reference:(BU AC = 1): <1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:COLORED VISCOUS PASTE, HYDROCARBON ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG ACIDS.
Stability Condition to Avoid:EXTREME HEAT, DIRECT SUNLIGHT, OPEN
FLAMES, SPARKS, & OTHER IGNITION SOURCES, FREEZING.
Hazardous Decomposition Products:ACRID SMOKE, OXIDES OF CARBON, OXIDES
OF NITROGEN
==================== Disposal Considerations ====================
Waste Disposal Methods:MAY BE COMPATIBLE W/INDUSTRIAL WASTE
INCINERATION OR FUEL-BLENDING PROGRAMS. DISPOSE I/A/W LOCAL, STATE
& FEDERAL REGUALTIOS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:6603020 T1-RD1
Preparer's Name:S HEALY
CAGE:FO645
CAGE:FO645
CAGE:6Z677
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM AZIDE, AZIDE *96-4*
CAS:26628-22-8
RTECS #:VY8050000
Other REC Limits:0.1 PPM
ACGIH TLV:C 0.29 MG/CUM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: NASAL IRRITATION. SKIN:
IRRITATION, ABSORPTION, ALLERGIC REACTION. EYES: IRRITATIONS,
CONJUNCTIVITIS. INGESTION: BRONCHIAL IRRITATION, RESPIRATORY
IRRITATION, RESPIRATORY FAILURE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, HEADACHE, DIZZINESS, FAINTNESS,
NAUSEA, LOW BLOOD PRESSURE, BLURRED VISION, SHORTNESS OF BREATH,
COLLAPSE, BRONCHITIS, PALPITATION, WEAKNESS & UNSTEADINESS, COMA,
CONVULSIONS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE CPR.
IF BREATHING IS DIFFICULT GIVE OXYGEN. SKIN: WASH OFF THOROUGHLY
FOR 15 MINS. EYES: RINSE THOROUGHLY W/WATER & GIVE PLENTY OF WATER
TO DRIN K. INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:DRY CHEMICALS SUCH AS AN SODIUM CARBONATE/SAND.
Fire Fighting Procedures:BURNING SODIUM AZIDE WILL EXPLODE IF WATER IS
USED AS AN EXTINGUISHING MEDIA. SCBA MUST BE WORN.
Unusual Fire/Explosion Hazard:MAY EXPLODE & RELEASE TOXIC FUMES UPON
HEATING. DON'T ALLOW TO CONTACT METALS AT HIGH TEMPS.
(SUPP)
================== Accidental Release Measures ==================
Spill Release Procedures:DILUTE W/RUNNING WATER BEFORE DISCHARGE.
DISPOSE OF IAW/FEDERAL, STATE & LOCAL REGULATIONS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM METALS & ACIDS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED
Ventilation:GENERAL/LOCAL EXHAUST TO MEET TLV REQUIREMENTS
Other Protective Equipment:ADEQUATE LABORATORY ATTIRE
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
UNUSUAL FIRE CONT'D: FORMS HIGHLY SENSITIVE EXPLOSIVE COMPOUNDS W/HEAVY
METALS SUCH AS LEAD, SILVER & COPPER. WHEN HEATED TO 662F IT
DECOMPOSES EXOTHERMICALLY, BURNING W/A VERY HOT FLAME & PRODUCING N
ITROGEN & MOLTEN SODIUM.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:527F
Spec Gravity:1.85
Solubility in Water:40.16
Appearance and Odor:WHITE-COLORLESS CRYSTALS/POWDER, ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
METALS, ACIDS, ACID CHLORIDES & STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HEAT
Hazardous Decomposition Products:NITROGEN OXIDES, HYDRAZOIC ACID
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TX1165, TRIFLUOROTRICHLOROETHANE
CAGE:DO242
CAGE:63612
CAGE:DO242
============= Composition/Information on Ingredients =============
Ingred Name:ETHANE, 1,1,2-TRICHLORO-1,2,2-TRIFLUORO-; (1,1,2,
TRICHLOROTRIFLUOROETHANE)
CAS:76-13-1
RTECS #:KJ4000000
OSHA PEL:1000PPM; 1250STEL
ACGIH TLV:1000PPM; 1250STEL
Ozone Depleting Chemical:1
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(ORAL RAT) 43 G/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:LEVELS OF 2500 PPM CAUSE DROW, LOSS OF
CONC & POSS NARCOS. POSS CARD ARRHYTHMIA AT HIGH CONC. LIQ/VAP
IRRITATING TO SKIN, EYES OR MUC MEMB. CHLOROFLUOROCARBON MATLS HAVE
PRDCED SENSIT OF MYOCARDIUM TO EPINEPHRINE IN LAB ANIMALS & COULD
HAVE A SIMILAR EFT IN HUMANS. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:ADRENOMIMETICS (E.G. EPINEPHRINE) MAY
BE CONTRAINDICATED EXCEPT FOR LIFE-SUSTAINING USES IN HUMANS
ACUTELY OR CHRONCIALLY EXPOSED TO CHLOROFLUOROCARBONS .
Medical Cond Aggravated by Exposure:HEART CONDITIONS.
======================= First Aid Measures =======================
First Aid:GET MEDICAL ASSISTANCE FOR ALL CASES OF OVEREXPOSURE.
SKIN:WASH THOROUGHLY W/SOAP & WATER. EYE:IMMEDIATELY FLUSH
THOROUGHLY W/WATER FOR AT LEAST 15 MINS. INHAL:REMOVE TO FRESH AIR;
GIVE ARTIFICIAL RES PIRATION IF BREATHING HAS STOPPED. INGEST:DO
NOT INDUCE VOMITING; GET IMMEDIATE MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NON-COMBUSTIBLE
Extinguishing Media:USE ANY SUITABLE MEDIA FOR ADJACENT MATERIAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED PRESSURE DEMAND SCBA
& FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:THERMAL DECOMPOSITION PRODUCES TOXIC
FUMES. THERMAL DECOMPOSITION PRODUCTS MAY INCLUDE CHLORIDES,
FLUORIDES & PHOSGENE .
================== Accidental Release Measures ==================
Spill Release Procedures:DIKE SPILL, TAKE UP W/ABSORBENT & CONTAINERIZE
FOR PROPER DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY AREA AWAY FROM
IGNITION SOURCES & OXIDIZERS. KEEP CONTAINER TIGHTLY CLOSED. DO NOT
BREATHE VAPOR. DO NOT TAKE INTERNALLY.
Other Precautions:DO NOT GET IN EYES, ON SKIN OR ON CLOTHING. NO
SMOKING IN AREA OF USE. DO NOT USE IN THE GENERAL VICINITY OF ARC
WELDING, OPEN FLAMES OR HOT SURFACES. HEAT &/OR UV RADIATION MAY
CAUSE THE FORMATION OF CHLORIDES, FLUORIDES & PHOSGENE .
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR SHOULD BE WORN IN
THE ABSENCE OF ADEQUATE VENTILATION.
Ventilation:MATERIAL SHOULD BE HANDLED/TRANSFERRED IN AN APPROVED FUME
HOOD OR W/ADEQUATE VENTILATION.
Other Protective Equipment:EYE WASH & SAFETY EQUIPMENT SHOULD BE
READILY AVAILABLE.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:118F,48C
Melt/Freeze Pt:M.P/F.P Text:-33F,-36C
Vapor Pres:334 @ 20C
Vapor Density:6.5
Spec Gravity:1.57 (H2O=1)
Solubility in Water:SLIGHT
Appearance and Odor:COLORLESS LIQUID; SLIGHT ETHER ODOR.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS. MAY REACT EXPLOSIVELY ON CONTACT W/ACTIVE METALS: NA, K, BA,
AL, BE, MG, ZN, TITANIUM, LITHIUM & SAMARIUM.
Stability Condition to Avoid:HEAT, FLAME & TEMPERATURES >200C.
Hazardous Decomposition Products:HALOGEN ACIDS, HALOGENS, CARBONYL
HALIDES & PHOSGENE. CHLORIDES, FLUORIDES .
==================== Disposal Considerations ====================
Waste Disposal Methods:TO BE PERFORMED IN COMPLIANCE W/ALL CURRENT
LOCAL, STATE & FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:DUROMAR SAR-BASE
CAGE:HO129
CAGE:HO129
============= Composition/Information on Ingredients =============
Ingred Name:FUNCTIONAL SILANE
Fraction by Wt: 0.5%
ACGIH TLV:5 PPM (MFR)
Ingred Name:SILICON OXIDE
Fraction by Wt: 0.5%
Ingred Name:SILICON CARBIDE
CAS:409-21-2
RTECS #:VW0450000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:ALPHA-ALUMINA (ALUMINUM OXIDE) (EPA LISTS ONLY FIBROUS
FORMS) (SARA III)
CAS:1344-28-1
RTECS #:BD1200000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:EPOXIDE
===================== Hazards Identification =====================
Effects of Overexposure:EYE/SKIN: IRRITATION,DERMATITIS.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH WITH WATER 15 MINUTES. SKIN:WASH WITH SOAP 6 WATER.
INGESTION:INDUCE VOMITING & GIVE A BLAND LIQUID SUCH AS MILK,SEEL
MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:390F/198C (CC)
Extinguishing Media:DRY CHEMICAL,FOAM,CARBON DIOXIDE
Fire Fighting Procedures:SELF-CONTAINED BREATHING APPARATUS
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL SPILLAGE CAN BE WIPED CLEAN WITH A
SOLVENT RAG. LARGE SPILLS TAKE UP WITH ABSORBENT MATERIAL &
CONTAINERIZED FOR DISPOSAL
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY AREA IN CLOSED
CONTAINERS.
Other Precautions:WASH AFTER HANDLING & BEFORE -EATING.DRINKING OR
SMOKING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESP DEVICE IN ACCORD WITH
EXPOSURE OF CONCERN.
Ventilation:LOCAL EHAUST
Other Protective Equipment:IMPERVIOUS CLOTHING
Supplemental Safety and Health
PART A OF A TWO PART KIT. MFR ADDRESS: 85 RESEARCH ROADK HINGHAM, MA
02043.
================== Physical/Chemical Properties ==================
HCC:N1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:PASTE/NEGLIGIBLE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:CARBON DIOXIDE,CARBON MONOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL,STATE AND
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:NPM-108 DEF SOLUTION FOR METHOD 507
CAGE:0MU35
CAGE:0MU35
============= Composition/Information on Ingredients =============
Ingred Name:METHYL TERT BUTYL ETHER (MTBE), 2-METHOXY-2-METHYL PROPANE
CAS:1634-04-4
RTECS #:KN5250000
Fraction by Wt: 99.87%
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:DEF
CAS:78-48-8
RTECS #:TG5425000
Fraction by Wt: 0.132%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TOXIC, IRRITANT
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION
======================= First Aid Measures =======================
First Aid:EYE/SKIN: FLUSH W/COPIOUS AMOUNTS OF WATER. INHALATION:
REMOVE TO FRESH AIR. GIVE OXYGEN IF NEEDED. OBTAIN MEDICAL
ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:CO2, DRY CHEMICAL POWDER, WATER SPRAY.
================== Accidental Release Measures ==================
Spill Release Procedures:A LEAKING BOTTLE MAY BE PLACED IN A PLASTIC
BAG & NORMAL DISPOSAL PROCEDURES FOLLOWED. LIQUID SAMPLES MAY BE
ABSORBED ON VERMICULITE/SAND.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP TIGHTLY CLOSED & STORE IN A COOL,
DRY PLACE. ALL CHEMICALS SHOULD BE CONSIDERED HAZARDOUS - DIRECT
PHYSICAL CONTACT SHOULD BE AVOIDED.
Other Precautions:THIS MATERIAL SHOULD ONLY BE USED BY THOSE TRAINED IN
THE SAFE HANDLING OF HAZARDOUS CHEMICALS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE APPROPRIATE OSHA/MSHA APPROVED SAFETY
EQUIPMENT.
Other Protective Equipment:CHEMICAL RESISTANT CLOTHING, LAB COAT,
RUBBER APRON.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Appearance and Odor:COLORLESS LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
==================== Disposal Considerations ====================
Waste Disposal Methods:BURN IN A CHEMIAL INCINERATOR EQUIPPED W/AN
AFTERBURNER & SCRUBBER. DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:AOSYN 900;MIL-L-63460D
Preparer's Name:N.R.NETZEL
CAGE:VELSI
CAGE:0Z6C4
CAGE:VELSI
============= Composition/Information on Ingredients =============
Ingred Name:PETROLEUM SOLVENT
Fraction by Wt: 20%
Other REC Limits:NONE RECOMMENDED
Ingred Name:ORGANOBARIUM COMPOUND
Fraction by Wt: <5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:BARIUM (SARA 313)
CAS:7440-39-3
RTECS #:CQ8370000
Fraction by Wt: 1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.5 MG/M3
Ingred Name:ORGANOMETALLIC COMPOUNDS
Fraction by Wt: <10%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15 MG/M*3
ACGIH TLV:10MG/MG*3
===================== Hazards Identification =====================
LD50 LC50 Mixture:TLV FOR OIL MIST IS 5MG/M3
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES:MAY CAUSE SEVERE
IRRITATION.SKIN:MAY CAUSE MODERATE IRRITATION.INGEST:MAY CAUSE GI
TRACT IRRITATION.MAY DAMAGE LUNGS IF VOMITED AFTER
SWALLOWING.INHAL:MAY CAUSE MODERATE RESPIRATORY IRRITATION AN D CNS
EFFECTS.
Explanation of Carcinogenicity:NONE OF THE INGREDIENTS IN THIS PRODUCT
IS LISTED BY NTP, IARC OR OSHA AS A CARCINOGEN.
Effects of
Overexposure:INHAL:HEADACHE,DIZZINESS,DROWSINESS,UNCONSCIOUSNESS.
Medical Cond Aggravated by Exposure:BECAUSE OF ITS DEFATTING
PROPERTIES, PROLONGED AND REPEATED SKIN CONTACT MAY AGGRAVATE AN
EXISTING DERMATITIS.
======================= First Aid Measures =======================
First Aid:SKIN:REMOVE CONTAMINATED CLOTHING;WASH WITH SOAP AND
WATER.EYES:FLUSH WITH WATER FOR 15 MINUTES.CALL PHYSICIAN IF
IRRITATION DEVELOPS.INHAL:REMOVE TO FRESH AIR.GIVE OXYGEN OR
ARTIFICIAL RESPIRATION IF NEEDED.INGEST:DO NOT INDUCE VOMITING.GET
PROMPT QUALIFIED MEDICAL ATTENTION.NOTE TO PHYSICIAN:TREAT
SYMPTOMATICALLY.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:165F,74C
Extinguishing Media:WATER FOG,DRY CHEMICAL,CARBON DIOXIDE,FOAM.AVOID
SPREADING BURNING LIQUID WITH WATER STREAM.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED
CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE SOURCES OF IGNITION.USE PROPER
RESPIRATORY AND PROTECTIVE EQUIPMENT.VENTILATE AREA.SOAK UP WITH A
NON-COMBUSTIBLE INERT ABSORBANT(CLAY,SAND);PLACE IN PROPER
CONTAINER FOR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE WITH
ADEQUATE VENTILATION. KEEP AWAY FROM HEAT, OPEN FLAMES AND STRONG
OXIDANTS. KEEP CONTAINERS TIGHTLY CLOSED.
Other Precautions:AVOID EYE AND SKIN CONTACT. DO NOT BREATHE VAPORS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED. NIOSH/MSHA-APPROVED
RESPIRATOR OR SCBA AS APPROPIATE FOR EXPOSURE OF CONCERN.
Ventilation:USE GENERAL DILUTION VENTILATION.
Other Protective Equipment:PROTECTIVE CLOTHING,AS NEEDED.PROVIDE A
LOCAL EYE WASH STATION AND SAFETY SHOWER.
Work Hygienic Practices:WASH HANDS.SEPERATE WORK CLOTHES FROM STREET
CLOTHES.LAUNDER WORK CLOTHES BEFORE REUSE.KEEP FOOD OUT OF THE WORK
AREA.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:V4
Boiling Pt:B.P. Text:>400F,>204C
Melt/Freeze Pt:M.P/F.P Text:-74F,-59C
Vapor Density:>1
Spec Gravity:0.86
Evaporation Rate & Reference:<1 (N-BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:LIGHT YELLOW TO BROWN LIQUID,MILD SOLVENT ODOR.
Percent Volatiles by Volume:NIL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES AND OTHER SOURCES
OF IGNITION
Hazardous Decomposition Products:CARBON DIOXIDE,CARBON MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTACT YOUR LOCAL ENVIRONMENTAL OFFICER.
DISPOSE OF IN ACCORDANCE WITH ALL FEDERAL,STATE AND LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:RUST EATER OIL/ALKYD GLOSS ENAMEL, 5766 STO
CAGE:85231
CAGE:59019
CAGE:85231
============= Composition/Information on Ingredients =============
Ingred Name:VENT: BELOW APPLICABLE EXPOSURE LIMITS. REFER TO OSHA
STANDARDS 1910.94, 1910.107, 1910.108.
RTECS #:9999999ZZ
Ingred Name:KEROSENE (PETROLEUM), HYDROTREATED; (MINERAL SPIRITS). VP:
2
CAS:64742-47-8
RTECS #:OA5504000
Fraction by Wt: 0-45%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
Ingred Name:MINERAL SPIRITS; (MINERAL SPIRITS 140-FLASH). VP: 0.5
CAS:64742-88-7
Fraction by Wt: 0-50%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
Ingred Name:ETHYLENE GLYCOL. VP: 0.1
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: 0-5%
OSHA PEL:50 PPM, C
ACGIH TLV:50 PPM,VAPOR, C
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE).
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 0-25%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:WASTE DISP METH: INCINERATE CLOSED CONTAINER. DISP OF I/A/W
FEDERAL, STATE AND LOCAL REGULATIONS REGARDING POLLUTION.
RTECS #:9999999ZZ
Ingred Name:EFTS OF OVEREXP: HAVE ASSOC RPTD & PRLNG OVEREXP TO
SOLVENTS WITH PERMANENT BRAIN & NERVOUS SYS DMG. HDCHE, (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6: DIZZ, NAUSEA & LOSS OF COORDINATION ARE INDICATIONS
OF EXCESS EXPOS TO VAPS/SPRAY MIST. REDNESS & ITCHING (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7: OR BURNING SENSATION MAY INDICATE EYE OR EXCESSIVE
SKIN EXPOSURE.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC: AVOID CONTACT WITH SKIN AND EYES. THIS COATING
MAY CONTAIN MATLS CLASSIFIED AS NUISANCE PARTICULTES (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9: SUCH AS TITANIUM DIOXIDE/CALCIUM CARBONATE, WHICH
MAY BE PRESENT AT HAZ LEVELS ONLY DURING SANDING OR (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10: ABRADING OF THE DRIED FILM.
RTECS #:9999999ZZ
Ingred Name:RESP PROT: WEAR NIOSH/MSHA APPROVED PARTICULATE RESP FOR
PROT AGAINST NON-VOLATILE MATLS IN INGRED SECTION.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:IRRIT OF EYES, SKIN & RESP SYS.
MAY CAUSE NERV SYS DEPRESS. EXTREME OVEREXP MAY RSLT IN UNCON &
POSSIBLY DEATH. CHRONIC: ETHYLENE GLYCOL IS CONSIDERED AN ANIMAL
TERATOGEN. IT HAS BEEN SHOWN TO C AUSE BIRTH DEFECTS IN RATS & MICE
AT HIGH DOSES WHEN GIVEN IN DRINKING H*2O/BY GAVAGE. THERE IS NO
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: EVIDENCE TO INDICATE IT CAUSES BIRTH
DEFECTS IN HUMANS. PRLNG OVEREXP TO SOLV INGRED LISTED IN INGRED
SEC MAY CAUSE ADVERSE EFTS TO LIVER & URINARY SYS. RATS EXPOS TO
TITANIUM DIOXIDE DUST @ 250 MG/M3 DEVELOPED LUNG CANCER, HOWEVER,
SUCH EXPOS LEVELS ARE NOT ATTAINABLE IN THE WORKPLACE. REPORTS (ING
6)
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.
======================= First Aid Measures =======================
First Aid:INHAL: IF AFFECTED, REMOVE FROM EXPOSURE. RESTORE BREATHING.
KEEP WARM AND QUIET. SKIN: WASH AFFECTED AREA THOROUGHLY WITH SOAP
AND WATER. EYES: FLUSH EYES WITH LARGE AMOUNTS OF WATER FOR AT
LEAST 15 MIN. GET MEDICAL ATTENTION. INGEST: GETMD IMMEDIATELY .
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:100F,38C
Lower Limits:0.9 %
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP .
H*2O SPRAY MAY BE INEFTIVE. IF H*2O IS USED, FOG NOZZ ARE
PREFERABLE. H*2O MAY BE USED TO COOL CLSD (SUPP DATA)
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM
HEAT/ELEC EQUIP/SPARKS/OPEN FLAME. CLSD CNTNRS MAY EXPLO WHEN
EXPOS TO EXTREME HEAT. APPLICATION TO HOT SURF (SUPP DATA)
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:CONTENTS ARE COMBUST. KEEP AWAY FROM
HEAT/OPEN FLAME. CONSULT NFPA CODE. USE APPRVD BONDING & GROUNDING
PROCEDURES. KEEP CNTNRS CLSD WHEN NOT IN USE.
Other Precautions:TRANSFER ONLY TO APPRVD CNTNRS W/COMPLETE & APPROP
LABELING. DO NOT TAKE INTERNALLY. KEEP OUT OF THE REACH OF
CHILDREN. INTENTIONAL MISUSE BY DELIB CONC & INHALING CONTENTS CAN
BE HARMFUL/FATAL. AVOID BREATHING VAPOR & SPRAY MIST. (ING 9)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF PERSONAL EXPOS CANNOT BE CONTROLLED BELOW
APPLIC LIMITS BY VENT, WEAR A PROPERLY FITTED NIOSH/MSHA APPRVD ORG
VAP/PARTICULATE RESP FOR PROT AGAINST MATLS IN ING SEC. WHEN
SANDING/WIREBRUSHING/ABRAD ING/WELDING THE DRIED FILM, (ING 12)
Ventilation:USE ONLY W/ADEQ VENT. LOC EXHST PREFERABLE. GEN EXHST
ACCEPTABLE IF EXPOS TO MATLS IN INGRED SEC IS MAINTAINED (ING 13)
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH HANDS AFTER USING.
Supplemental Safety and Health
EXPLO HAZ: REQUIRES SPECIAL PRECAUTIONS. DURING EMERGENCY CONDITIONS
OVEREXPOSURE TO DECOMP PRODUCTS MAY CAUSE A HEALTH HAZARD. SYMPTOMS
MAY NOT BE IMMEDIATELY APPARENT. OBTAIN MEDICAL ATTENTION. FIRE
FIGHT PROC: CONTAINERS TO PREVENT PRESS BUILD-UP AND POSSIBLE
AUTIOIGNITION OR EXPLOSION WHEN EXPOSED TO EXTREME HEAT.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:>240F,116C
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Spec Gravity:0.9-1.2
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:49-66
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:BY FIRE: CARBON DIOXIDE, CARBON
MONOXIDE, OXIDES OF METALS IN INGREDIENT SECTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE FORM PROD MAY BE HAZ AS DEFINED UNDER RCRA
40 CFR 261. WASTE MUST BE TESTED FOR IGNIT TO DETERMINE THE
APPLICABLE EPA HAZ WASTE NO. WASTE CNTNG CHROMIUM OXIDE (385) MUST
BE TESTED FOR EXTRACTABI LITY. INCIN IN APPRVD FACILITY. DO NOT
(ING 5)
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:DRY BULK ZONOLITE CONCRETE AGGREGATE
CAGE:1BX64
CAGE:17486
CAGE:1BX64
============= Composition/Information on Ingredients =============
Ingred Name:VERMICULITE; (MAGNESIUM-ALUMINOSILICATE MINERAL). PEL: 15
MG/M3 TDUST; 5 RDUST (MFR). TLV: 10 MG/M3 TDUST;5RDUST (MFR)
CAS:1318-00-9
OSHA PEL:SEE INGREDIENT NAME
ACGIH TLV:SEE INGREDIENT NAME
Ingred Name:TREMOLITE (RESPIRABLE FIBER)
CAS:14567-73-8
RTECS #:XX2200000
Fraction by Wt: <0.005%
OSHA PEL:2 FIBERS/CC
ACGIH TLV:2 MG/M3
Ingred Name:SPEC GRAV: 4-7 PCF (BULK DENSITY) (H*2O=1)
RTECS #:9999999ZZ
Ingred Name:RESP PROT: I/A/W (29CFR1910.1001) (G) RESPIRATORY
PROTECTION.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL: VERMICULITE DUST
RELEASED IN HNDLG MAY CAUSE SYMPS TYPICAL OF NUISANCE DUSTS INCL
COUGH, SNEEZE, & MINOR UPPER RESP IRRIT. SKIN & EYE: DIRECT EYE
CONT MAY CAUSE MINOR PHYSICAL/MECH IRRIT . SKIN CONT NOT EXPECTED
TO CAUSE ANY HARMFUL EFTS. INGEST: VERMICULITE IS NOT CONSIDERED
HARMFUL BY (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:INGEST. PROD USE W/OUT PROPER
ENGINEERING CTLS MAY REL TREMOLITE FIBERS, A FORM OF ASBESTOS.
ACCDG TO NTP, IARC & OSHA 29 CFR 1910.1001, ASBESTOS FIBERS CAN
CAUSE A DISABLING RESP DISEASE & V ARIOUS TYPES OF DISEASE IF
FIBERS ARE INHALED. RISK OF DISEASE IS SIGNIFICANTLY INCR BY
SMOKING. INGEST OF (SUPP DATA)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL: GET FRESH AIR. IF SYMPTOMS PERSIST CONSULT A
PHYSICIAN. EYES: FLUSH WITH PLENTY OF WATER FOR AT LEAST 15
MINUTES. IF IRRITATION, BLINKING OR TEARING PERSIST CONSULT A
PHYSICIAN. SKIN: FLUSH WIT H COPIOUS AMOUNTS OF WATER. CALL MD
INGEST: CALL MD IMMED .
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:USE METHODS TO CLEAN SPILL WHICH AVOID
CREATING AIRBORNE DUST. REMOVE FOR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:INHAL OF DUST MAY CAUSE SNEEZING.
INHAL OF AIRBORNE TREMOLITE FIBERS MAY CREATE CANCER & LUNG DISEASE
HAZ. EYE CONT MAY CAUSE MINOR PHYSICAL IRRIT.
Other Precautions:AVOID CREATING DUST. AVOID CONT W/EYES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:A NIOSH/MSHA APPRVD TYPE TC-21C-XXX DUST RESP IS
RECOM TO CONTROL EXPOS TO VERMICULITE DUST W/IN LIM. IF HNDLG RSLTS
IN EXPOS TO TREMOLITE FIBER IN EXCESS OF PERMISSIBLE EXPOS LEVEL,
NIOSH/MSHA APPRVD RESP PROT MUST BE PROVIDED (ING 4)
Ventilation:LOC EXHAUST/MECH: RECOMMENDED. SPECIAL: REFER TO 29CFR
1910.1001(F) METHODS OF COMPLIANCE.
Other Protective Equipment:REFER TO 29CFR1910.1001(H) PROTECTIVE WORK
CLOTHING AND EQUIPMENT.
Work Hygienic Practices:OBSERVE PRECAUTIONS NOTED ABOVE.
Supplemental Safety and Health
EFTS OF OVEREXP: FIBERS HAS ALSO BEEN ASSOC W/INCR RISK OF DISEASE.
DISEASES ASSOC W/ASBESTOS FIBER INCL "LUNG CANCER, MESOTHELIOMA, &
CANCER OF STOM & COLON". MESOTHELIOMA IS A RARE CANCER OF THIN ME
MB LINING OF CHEST & ABDOMEN. SYMPS OF MESOTHELIOMA INCL SHORT OF
BRTH, PAIN IN WALLS OF CHEST &/OR ABDOM PAIN.
================== Physical/Chemical Properties ==================
Vapor Pres:NONE
Vapor Density:NONE
Spec Gravity:ING 3
Solubility in Water:NEGLIGIBLE
Appearance and Odor:FREE FLOWING PARTICLES, BROWN TO GRAY IN COLOR
Percent Volatiles by Volume:NONE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:NONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:ACCORDING TO EPA (40CFR261.3) WASTE OF THIS
PRODUCT IS NOT DEFINED AS HAZARDOUS. DISPOSE OF ALL WASTE IN
ACCORDANCE WITH FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:KIDDIE KARE CREME CONDITIONER
CAGE:DO898
CAGE:DO898
============= Composition/Information on Ingredients =============
Ingred Name:NON HAZARDOUS INGREDIENT
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NO HEALTH HAZARDS.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:NONE
Medical Cond Aggravated by Exposure:NONE
======================= First Aid Measures =======================
First Aid:IF PRODUCT GETS INTO EYES - FLUSH WITH COPIOUS AMOUNT OF
WATER. IF INGESTED - CONSULT A PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>149F,>65C
Lower Limits:ND
Upper Limits:ND
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED
CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN SPILL AREA WITH SOAP WATER. DRY AREA
IMMEDIATELY.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN AMBIENT ENVIRONMENT.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE
Ventilation:NA
Other Protective Equipment:NA
Work Hygienic Practices:WASH WITH SOAP AND RINSE WITH WATER.
Supplemental Safety and Health
NA
================== Physical/Chemical Properties ==================
HCC:V4
Melt/Freeze Pt:M.P/F.P Text:NA
Vapor Pres:ND
Vapor Density:NA
Spec Gravity:0.845
Evaporation Rate & Reference:ND
Solubility in Water:APPRECIABLE
Appearance and Odor:CREAM/SOFT-N-SWEET FRAGRANCE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:AVOID EXTREMELY HIGH TEMPERATURES.
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL OF WASTE SHALL COMPLY WITH LOCAL, STATE
AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:146 3462,KODAK SODIUM CARBONATE (MONOHYDRATES)
Resp. Party Other MSDS Num.:200000925/F/USA
CAGE:19139
CAGE:19139
CAGE:5K871
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM CARBONATE,MONOHYDRATE
CAS:5968-11-6
= Wt:100.
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT) IS 1600-3200 MG/KG.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EFFECTS OF EXPOSURE: INHALATION:
AIRBORNE DUST IRRITATING. EYES: CAUSES IRRITATION. HOWEVER,
IMMEDIATE FLUSHING OF THE EYES WITH WATER WILL MINIMIZE ANY
IRRITATIVE EFFECT. SKIN: CAUSES IRRITATION. ING ESTION: HARMFUL IF
SWALLOWED. MAY CAUSE BURNS OF THE GASTROINTESTINAL TRACT IF
SWALLOWED.
Explanation of Carcinogenicity:CARCINOGENICITY CLASSIFICATION
(COMPONENTS PRESENT AT 0.1% OR MORE): - INTERNATIONAL AGENCY FOR
RESEARCH ON CANCER (IARC): NONE - AMERICAN CONFERENCE OF
GOVERNMENTAL INDUSTRIAL HYGIENISTS (ACGIH): NON E - NATIONAL
TOXICOLOGY PROGRAM (NTP): NONE - OCCUPATIONAL SAFETY AND HEALTH
ADMINISTRATION (OSHA): NONE
Effects of Overexposure:EFFECTS OF EXPOSURE: INHALATION: AIRBORNE DUST
IRRITATING. EYES: CAUSES IRRITATION. HOWEVER, IMMEDIATE FLUSHING OF
THE EYES WITH WATER WILL MINIMIZE ANY IRRITATIVE EFFECT. SKIN:
CAUSES IRRITATION. ING ESTION: HARMFUL IF SWALLOWED. MAY CAUSE
BURNS OF THE GASTROINTESTINAL TRACT IF SWALLOWED.
Medical Cond Aggravated by Exposure:NOT PROVIDED
======================= First Aid Measures =======================
First Aid:INHALATION: IF SYMPTOMATIC, MOVE TO FRESH AIR. TREAT
SYMPTOMATICALLY. GET MEDICAL ATTENTION IF SYMPTOMS PERSIST. EYES:
IMMEDIATELY FLUSH WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES. GET
MEDICAL ATTEN TION. SKIN: IMMEDIATELY FLUSH WITH PLENTY OF WATER
FOR AT LEAST 15 MINUTES WHILE REMOVING CONTAMINATED CLOTHING AND
SHOES. GET MEDICAL ATTENTION IF SYMPTOMS OCCUR. WASH CONTAMINATED
CLOTHING BEFORE RE USE. DESTROY OR THOROUGHLY CLEAN CONTAMINATED
SHOES. INGESTION: DO NOT INDUCE VOMITING. GIVE VICTIM A GLASS OF
WATER. NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. CALL
A PHYSICIAN OR POISON CONTROL CENTER IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point:NON-COMBUSTIBLE
Extinguishing Media:USE APPROPRIATE AGENT FOR ADJACENT FIRE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH TO SEWER WITH LARGE AMOUNTS OF WATER.
OTHERWISE, SWEEP UP AND PLACE IN ACONTAINER FOR CHEMICAL WASTE.
CLEAN SURFACE THOROUGHLY TO REMOVE RESIDUAL CONTAMINATION.
Neutralizing Agent:NOT PROVIDED
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED. KEEP AWAY FROM
INCOMPATIBLE SUBSTANCES (SEE INCOMPATIBILITY SECTION).
Other Precautions:AVOID PROLONGED OR REPEATED BREATHING OF DUST. AVOID
CONTACT WITH EYES, SKIN, AND CLOTHING. USE WITH ADEQUATE
VENTILATION. WASH THOROUGHLY AFTER HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF ENGINEERING CONTROLS DO NOT MAINTAIN AIRBORNE
CONCENTRATIONS TO AN ACCEPTABLE LEVEL, AN APPROVED RESPIRATOR MUST
BE WORN. RESPIRATOR TYPE: DUST
Ventilation:GOOD GENERAL VENTILATION (TYPICALLY 10 AIR CHANGES PER
HOUR) SHOULD BE USED. VENTILATION RATES SHOULD BE MATCHED TO
CONDITIONS.
APPROPRIATE FOR RISK OF EXPOSURE
Other Protective Equipment:EYE BATH, WASHING FACILITIES, SAFETY SHOWER
Work Hygienic Practices:NOT PROVIDED
Supplemental Safety and Health
SUPPLEMENTARY LOCAL EXHAUST VENTILATION, CLOSED SYSTEMS, OR RESPIRATORY
PROTECTION MAY BE NEEDED IN SPECIAL CIRCUMSTANCES SUCH AS POORLY
VENTILATED SPACES, MECHANICAL GENERATION OF DUSTS, HEATING, DRY
ING, ETC. IF RESPIRATORS USED, ASSURE COMPLIANCE WITH OSHA STANDARD
29CFR 1910.134 AND 29CFR 1910.1048.
================== Physical/Chemical Properties ==================
HCC:B3
NRC/State Lic Num:NOT RELEVANT
Melt/Freeze Pt:=851.1C, ######F
Vapor Pres:NEGLIGIBLE
Vapor Density:NOT APPLIC
Spec Gravity:2.25
Solubility in Water:APPRECIABLE
Appearance and Odor:WHITE SOLID - ODORLESS.
Percent Volatiles by Volume:NEGLIGIBLE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS
Stability Condition to Avoid:STABLE.
Hazardous Decomposition Products:NONE
Conditions to Avoid Polymerization:WILL NOT OCCUR.
=================== Toxicological Information===================
Toxicological Information:ORAL LD50: 1600-3200 MG/KG. SKIN IRRITATION:
SLIGHT.
===================== Ecological Information =====================
Ecological:NO BIOCHEMICAL OXYGEN DEMAND & NO POTENTIAL TO CAUSE OXYGEN
DEPLETION IN AQUEOUS SYSTEMS. LOW POTENTIAL TO AFFECT AQUATIC
ORGANISMS, LOW POTENTIAL TO BIOCONCENTRATE. WHEN DILUTED WITH LARGE
AMOUNT OF WATER, MATERIAL RELEASED DIRECTLY OR INDIRECTLY INTO
ENVIRONMENT IS NOT EXPECTED TO HAVE SIGNIFICANT EFFECT.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT, OR DISPOSAL MAY BE SUBJECT
TO NATIONAL, STATE, OR LOCAL LAWS. FLUSH TO SEWER WITH LARGE
AMOUNTS OF WATER. SINCE EMPTIED CONTAINERS RETAIN PRODUCT RESIDUE,
FOLLOW LABEL WARNINGS E VEN AFTER CONTAINER IS EMPTIED.
=================== MSDS Transport Information ===================
Transport Information:NOT REGULATED PER KODAK TRANSPORTATION HOTLINE.
===================== Regulatory Information =====================
SARA Title III Information:NOT PROVIDED
Federal Regulatory Information:NOT PROVIDED
State Regulatory Information:CONTAINS NO MATERIALS KNOWN TO STATE OF
CALIFORNIA TO CAUSE CANCER OR REPRODUCTIVE HARM.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:37 513GIL METAL PRETREATMENT, 0513GIL-123-A
CAGE:13418
CAGE:13418
============= Composition/Information on Ingredients =============
Ingred Name:TALC (POWDER), CONTAINING NO ASBESTOS FIBERS; (TALC)
CAS:14807-96-6
RTECS #:WW2710000
Fraction by Wt: 1%
OSHA PEL:2 MG/M3 RDUST
ACGIH TLV:2 MG/M3 RDUST
Ingred Name:CHROMIC ACID, ZINC SALT; (ZINC CHROMATE PIGMENT)
CAS:13530-65-9
RTECS #:GB3290000
Fraction by Wt: 10%
OSHA PEL:0.1 MG/M3 (CRO3),C
ACGIH TLV:0.01MG/M3 (CR)
Ingred Name:BUTYL ALCOHOL
CAS:71-36-3
RTECS #:EO1400000
Fraction by Wt: 20%
OSHA PEL:100 PPM
ACGIH TLV:S, C 50 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ISOPROPYL ALCOHOL
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 60%
OSHA PEL:400 PPM;500 PPM STEL
ACGIH TLV:400 PPM;500 PPM STEL
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:CAN BE ABSORBED THRU SKIN.
HARMFUL IF INHALED. MAY AFFECT BRAIN, NERVOUS SYSTEM, RESPIRATORY
SYSTEM, CAUSING DIZZINESS, HEADACHE, NAUSEA OR RESPIRATORY
IRRITATION. OVEREXP TO INGREDIENTS IN PROD UCT MAY CAUSE NOSE &
THROAT IRRITATION,EYE IRRITATION, SKIN IRRITATION, MUCOUS MEMBRANE
IRRITATION. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:ZINC CHROMATE: GROUP 1 (NTP, IARC).
Effects of Overexposure:HLTH HAZ:CHRONIC:CNTNS CHROMATES WHICH MAY
CAUSE CANCER. NOTICE:RPTS HAVE ASSOC RPTD & PRLNG OCCUPATIONAL
OVEREXP TO SOLVENTS WITH PERMANENT BRAIN & NERVOUS SYSTEM DAMAGE.
INTENTIONAL MISUSE BY DELIB CONC & INHALING CONTENTS MAY BE
HARMFUL/FATAL. CNTNS INGRED WHICH MAY CAUSE LIVER/KIDNEY DAMAGE,
HEARING LOSS.
Medical Cond Aggravated by Exposure:ANY RESPIRATORY OR SKIN CONDITION.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE FROM EXPOSURE AREA. IF BREATHING HAS STOPPED,
USE MOUTH-TO-MOUTH RESUSCITATION & GET MED ATTN. EYE: FLUSH WITH
WATER FOR AT LEAST 15 MIN. SKIN: WASH WITH SOAP AND WATER. INGEST:
GET MD IM MED .
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:59.0F,15.0C
Lower Limits:1.0%
Upper Limits:12%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM, AND/OR WATER
FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . CONTAINERS EXPOSED TO FIRE SHOULD BE KEPT
COOL WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. AVOID BREATHING OF VAPORS. USE
NIOSH/MSHA APPROVED SCBA OR AIRMASK FOR LG SPILLS IN CONFINED AREA.
ELIMINATE IGNITION SOURCES. REMOVE WITH INERT ABSORBENT AND
NON-SPARKING TOOLS. AVOID CONTACT WITH EYES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:CONTR SHOULD BE GROUND/BOND WHEN POUR.
AVOID FREE FALL OF LIQ IN EXCESS OF FEW IN. KEEP AWAY FROM
HEAT/SPARKS/OPEN FLAME. DO NOT STORE ABOVE 120F.
Other Precautions:KEEP CONTR CLSD WHEN NOT IN USE. BASED ON PROD FL PT
& VP SUITABLE STOR SHOULD BE PROVIDED I/A/W OSHA REGS 1910.106.
EMPTY CONTR MAY CNTN PROD RESIDUE, INCL FLAM/EXPLOS VAP. DO NOT
CUT/PUNCTURE/WELD O N OR NEAR CONTR. ALL LBL (SUPP DATA)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR NIOSH/MSHA APPROVED APPROP PROPERLY FITTED
RESP DURING & AFTER APPLICATN UNLESS AIR MONITORING VAP/MIST LEVELS
ARE BELOW APPLIC LIM. FOLLOW RESP MFR DIRECTIONS FOR RESPIRATOR
USE.
Ventilation:REQUIRED FOR SPRAY/IN CONFINED AREA. VENT EQUIP SHOULD BE
EXPLOS PROOF. ELIMINATE IGNIT SOURCES.
Other Protective Equipment:USUAL CLOTHING FOR PAINTING OPERATIONS.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
OTHER PREC:WARNINGS MUST BE OBSERVED UNTIL CONTAINER HAS BEEN CLEANED
OR RECONDITIONED.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:177F,81C
Vapor Pres:33.0@68F
Vapor Density:2.6
Spec Gravity:0.89
Evaporation Rate & Reference:1.7(BUTYL ACETATE=1)
Solubility in Water:YES
Appearance and Odor:NORMAL FOR A COATINGS PRODUCT.
Percent Volatiles by Volume:90.18
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:HALIDES, CARBON DIOXIDE/MONOXIDE,
METAL OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN CHEMICAL DISPOSAL AREA OR IN MANNER
THAT COMPLIES WITH LOCAL, STATE, AND FEDERAL REGULATIONS. DO NOT
INCINERATE CLOSED CONTAINERS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SOLID COLOR LATEX STAIN H 101
CAGE:DO693
CAGE:54636
CAGE:DO693
============= Composition/Information on Ingredients =============
Ingred Name:ETHYLENE GLYCOL (SARA III)
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: <5%
OSHA PEL:C 50 PPM
ACGIH TLV:C 50 PPM,VAPOR; 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:MICA
CAS:12003-38-2
Fraction by Wt: <5%
ACGIH TLV:3
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 0-15%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:IRRITATION OF EYES,SKIN AND UPPER
RESPIRATORY SYSTEM.IN A CONFINED AREA VAPORS IN HIGH CONCENTRATION
MAY CAUSE HEADACHE,NAUSEA OR DIZZINESS.
Effects of Overexposure:REDNESS AND ITCHING OR BURNING SENSATION MAY
INDICATE EYE OR EXCESSIVE SKIN EXPOSURE.
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.
======================= First Aid Measures =======================
First Aid:INHALATION:IF AFFECTED,REMOVE FROM EXPOSURE.RESTORE
BREATHING.KEEP WARM AND QUIET.SKIN:WASH AFFECTED AREA THOROUGHLY
WITH SOAP AND WATER.REMOVE CONTAMINATED CLOTHING AND LAUNDER BEFORE
RE-USE.EYES:FLU SH EYES W/LARGE AMOUNTS OF WATER FOR 15MINUTES.GET
MEDICAL ATTEN.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>199F
Extinguishing Media:CARBON DIOXIDE,DRY CHEMICAL,ALCOHOL FOAM
Fire Fighting Procedures:FULL PROTECTIVE EQUIPMENT INCLUDING
SELF-CONTAINED BREATHING APPARATUS.WATER MAY BE INEFFECTIVE.IF
WATER IS USED,FOG NOZZLES ARE PREFERABLE.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE (DUE TO THE
BUILD-UP OF PRESSURE) WHEN EXPOSED TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION.VENTILATE AND
REMOVE WITH INERT ABSORBENT.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED WHEN NOT IN
USE.TRANSFER ONLY TO APPROVED CONTAINERS WITH COMPLETE AND
APPROPRIATE LABELING.KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF PERSONAL EXPOSURE CANNOT BE CONTROLLED BELOW
APPLICABLE LIMITS BY VENTILATION,WEAR A PROPERLY FITTED ORGANIC
VAPOR/PARTICULATE RESPIRATOR APPROVED BY NIOSH/MSHA FOR PROTECTION.
Ventilation:LOCAL EXHAUST PREFERABLE,GENERAL EXHAUST ACCEPTABLE.
Work Hygienic Practices:WASH HANDS AFTER USING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212-388 F
Vapor Density:>THAN AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:61-63
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:CARBON DIOXIDE,CARBON MONOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE IN APPROVED FACILITY.DO NOT
INCINERATE CLOSED CONTAINER.DISPOSE OF IN ACCORDANCE WITH
FEDERAL,STATE AND LOCAL REGULATIONS REGARDING POLLUTION.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:INTERPON 600 SERIES ZINC PRIMER JW102U PRIM
CAGE:69827
CAGE:69827
============= Composition/Information on Ingredients =============
Ingred Name:1,3,5-TRIGLYCIDYL ISOCYANURATE
CAS:2451-62-9
Fraction by Wt: <10%
ACGIH TLV:0.25 MG/M3 (MFR)
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: <40%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:ZINC (SARA III)
CAS:7440-66-6
RTECS #:ZG8600000
Fraction by Wt: <60%
OSHA PEL:10 MG ZNO/M3
ACGIH TLV:10 MG ZNO/M3; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION MAY OCCUR. SKIN:
IRRITATION MAY OCCUR IN SUSCEPTIBLE INDIVIDUALS. INHAL: IRRITATION
MAY OCCUR IN SUSCEPTIBLE INDIVIDUALS. MAY CAUSE "METAL FUME FEVER",
ESPECIALLY IF FRESHLY FORMED ZI NC OXIDE PRESENT. INGEST: MAY CAUSE
GI IRRIT. PRLNG/RPTD EXPOSURE MAY CAUSE SENSITIZATION IN
SUSCEPTIBLE INDIVIDUALS.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH IMMEDIATELY W/PLENTY OF WATER FOR A MINIMUM OF 15
MINUTES & GET MEDICAL ATTN. SKIN: REMOVE CONTAMINATED CLOTHING.
WASH SKIN W/PLENTY OF SOAP & WATER. LAUNDER CLOTHES BEFORE REUSE.
IF IRRIT ATION PERSISTS GET MEDICAL ATTN. INHAL:REMOVE TO FRESH
AIR. IF DISCOMFORT PRESENT, GET MEDICAL ATTN. INGEST: GET MEDICAL
ATTN IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point:COMBUSTIBLE
Extinguishing Media:DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . DO NOT ALLOW POWDER TO BE DISPERSED INTO THE
AIR WHILE EXTINGUISHING.
Unusual Fire/Explosion Hazard:WHEN SUSPENDED IN AIR AS A DUST CLOUD,
THIS PROD IS A POTNTL FIRE/EXPLO HAZ. DECOMP/COMBUST PRODS MAY BE
TOX. MAY EXPLODE IN CONT W/OXIDIZING AGENTS.(SUPP DATA)
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. AVOID
INHALATION OF DUST. VENTILATE AREA.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID SKIN & EYE CONTACT. AVOID
BREATHING DUST OR VAPOR FROM HEATED PRODUCT DURING CURE.
Other Precautions:DO NOT USE NEAR SPARKS, OPEN FLAMES OR ANY OTHER
IGNITION SOURCE. DUST CLOUDS ARE A POTENTIAL FIRE & EXPLOSION
HAZARD. GROUND ALL EQUIPMENT TO PREVENT BUILDUP OF STATIC
ELECTRICITY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IN OUTDOOR/OPEN AREAS, W/UNRESTRICTED VENT, USE
NIOSH/MSHA APPRVD FILTER RESPIRATOR TO REMOVE SOLID AIR-BORNE
PARTICLES OF OVERSPRAY DURING SPRAY APPLICATN. IN RESTRICTED VENT
AREAS, USE NIOSH/MSHA AP PRVD RESPIRATOR I/A/W 29CFR (SUPP DATA)
Ventilation:PROVIDE SUFFICIENT VENT, IN VOL/PATTERN, TO KEEP TLV/LEL OF
HAZ INGREDS BELOW LIMITS SPECIFIED & TO REMOVE (SUPP DATA)
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health
EXPLO HAZ: ZINC REACTS W/WATER, SOME ACIDS & BASES TO PRDCE FLAMMABLE
HYDROGEN GAS. RESP PROT: 1910.134 TO REMOVE A COMBINATION OF
PARTICULATES & VAPORS FROM HEATED PRODUCT. VENT: DECOMPOSITION
PRODUC TS DURING WELDING OR FLAME CUTTING ON SURFACES COATED W/THIS
PRODUCT.
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:>1.2
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:DRY, FINELY GROUND PIGMENTED ORGANIC POWDER
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIALS.
Stability Condition to Avoid:AVOID HEAT, SPARKS, NAKED LIGHTS.
Hazardous Decomposition Products:CO, CO2, ALDEHYDES, NITROGEN
COMPOUNDS, VARIOUS HYDROCARBON FRAGMENTS, ZINC FUMES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH LOCAL, STATE, AND
FEDERAL REGULATIONS. DO NOT INCINERATE UNOPENED CONTAINERS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:F-150, 5429 GREEN PRIMER, MFR CODE G-452
Kit Part:Y
CAGE:85319
CAGE:85319
============= Composition/Information on Ingredients =============
Ingred Name:N-BUTYL ALCOHOL (SARA III)
CAS:71-36-3
RTECS #:EO1400000
Fraction by Wt: 28.1%
OSHA PEL:100 PPM
ACGIH TLV:S, C 50 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:POLYAMIDE/EPOXY ADDUCT
Fraction by Wt: 17.6%
Ingred Name:FATTY AMIDOAMINE ADDUCT
Fraction by Wt: 1.7%
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 8.4%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:IRON OXIDE
CAS:1309-37-1
RTECS #:NO7400000
Fraction by Wt: 1.7%
OSHA PEL:10 MG/M3 (FE)
ACGIH TLV:5 MG/M3(FE),B2; 9293
===================== Hazards Identification =====================
Effects of Overexposure:INH: ANESTHETIC. IRRIT RESP TRACT. ACUTE CNS
DEPRESS: HDACHE, DIZZ, UNCON, COMA. SKIN/EYE IRRIT.
======================= First Aid Measures =======================
First Aid:INH: REMOVE FROM EXPOSURE. RESTORE BRTH. KEEP WARM/QUIET.
CALL MD. EYES: FLUSH IMMED W/LG AMT WATER 15 MIN. TAKE TO MD. SKIN:
WASH W/WATER. REMOVE CONTAM CLOTHING. CONSULT MD.
===================== Fire Fighting Measures =====================
Flash Point:99F PMCC
Lower Limits:1.4
Extinguishing Media:CARBON DIOXIDE, DRY CHEM, FOAM
Fire Fighting Procedures:FULL PROT EQUIP, SELF-CNTND BRTH. WATER-COOL
CNTNR W/FOG NOZ
Unusual Fire/Explosion Hazard:CLOSE CNTNR TIGHT, ISOLATE FROM IGNIT
SOURCES. CLOSED CNTNR MAY EXPLODE WHEN EXPOSED TO EXTEME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. AVOID BRTHNG
VAPORS. VENT AREA. CONTAIN & REMOVE W/INERT ABSORBENT & NON
SPARKING TOOLS.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 100F. KEEP CLOSURE
TIGHT. DO NOT STORE OR USE NEAR HEAT, SPARKS, FLAME.
Other Precautions:DO NOT GET IN EYES. AVOID PROLONGED CNTCT W/SKIN,
BRTHNG OF VAPORS OR SPRAY MIST. DO NOT TAKE INTERN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPRVD
Ventilation:DILUTION OR LOCAL TO KEEP VAPORS BELOW TLV
Other Protective Equipment:USE PROT CREAM WHERE SKIN CNTCT LIKELY
Supplemental Safety and Health
EXT.& CNTD EXP MAY RESULT IN RESP.ALLGCSNSTVTY.ADD.INGRED: CASTOR OIL
DERIVATIVE-0.4%,MAGNESIUM SILICATE-42.0%&COPPER PHTHALOCYANINE
BLUE-0. 1%.WT/GAL-11.65-RAPPRESS IS GIVEN FOR N-BUTANOL.KEY1:J1.
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:241-247F
Vapor Pres:4
Vapor Density:>1
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:48.5
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HI TEMPS & CONTAM W/FOREIGN MATLS
Hazardous Decomposition Products:HAZ FUMES WHEN HEATED DECOMP
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IAW LOCAL, STATE, FED REG. INCINERATE IN
APPRVD FACILITY. DO NOT INCINERATE CLOSED CNTNRS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:EC-SPOT & STAIN CLEANER (ECSS101)
CAGE:0VE73
CAGE:0VE73
============= Composition/Information on Ingredients =============
Ingred Name:NO HAZARDOUS INGREDIENTS ACCORDING TO MANUFACTURER -
BIODEGRADEABLE
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT RELEVANT
ACGIH TLV:NOT RELEVANT
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CONTACT W/EYES CAN CAUSE MILD
IRRITATION. SKIN: CHRONIC CONTACT MAY CAUSE MILD IRRITATION.
Medical Cond Aggravated by Exposure:NO CHRONIC EFFECTS AND MEDICAL
CONDITIONS KNOWN.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/PLENTY OF WATER 15 MINUTES. SKIN: FLUSH
W/PLENTY WATER. INGESTION: DRINK PLENTY OF MILK/WATER TO DILUTE.
GET MEDICAL AID IF NECESSARY.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:NA (WATER SOLUTION)
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL: SOAK UP W/ABSORBENT, SHOVEL INTO WASTE
CONTAINER. LARGE: RECOVER LIQUID FOR REPROCESSING OR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:PROTECT DRUM FROM DAMAGE, FREEZING,
INTENSE HEAT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NORMALLY REQUIRED.
Ventilation:USE ADEQUATE VENTILATION.
Other Protective Equipment:RUBBER APRON & BOOTS. SAFETY SHOWER &
EYEWASH STATION.
Supplemental Safety and Health
PH 5% SOLUTION = 9.6
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:AS WATER
Vapor Pres:AS WATER
Vapor Density:1.0 G/CC
pH:<11.2
Evaporation Rate & Reference:<WATER
Solubility in Water:COMPLETE
Appearance and Odor:HAZY LIQUID, MILD ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS OR MINERAL ACIDS.
Hazardous Decomposition Products:NOTHING HAZARDOUS
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/FEDERAL, STATE, LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ISE DILUENT FOR USE WITH THE BM/HITACHI (SU
Preparer's Name:EILEEN MEULBROEK
CAGE:IO477
CAGE:IO477
CAGE:51169
============= Composition/Information on Ingredients =============
Ingred Name:BORIC ACID
CAS:10043-35-3
RTECS #:ED4550000
Fraction by Wt: <5%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:N/RTE/CHRONIC:THE TOXICOLOGICAL
EFFECTS OF THE FINISHED PRODUCT MAY HAVE NOT BEEN THOROUGHLY
INVESTIGATED AT THIS TIME. THIS SOLUTION MAY CAUSE SKIN AND EYE
IRRITATION AND MAY BE HARMFUL BY INHALATION , INGESTION OR
ABSORPTION. BORIC ACID IS PRESENT IN THIS PRODUCT AT <5%. BORIC
ACID EXOSURE CAN CAUSE (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:IRRITATION, CYANOSIS, VOMITING &
DIARRHEA.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE:IMMEDIATELY FLUSH WITH LARGE AMOUNTS OF FRESH WATER FOR
AT LEAST 15 MINUTES. HOLD THE EYELIDS APART WITH FINGERTIPS TO
ENSURE A COMPLETE FLUSH. GET MD. SKIN:WHILE REMOVING CONTAMINATED
CLOTHING, F LUSH THE AFFECTED BODY AREA WITH LARGE AMOUNTS OF FRESH
WATER. CONTINUE FOR 15 MINUTES. DO NOT REUSE CONTAM CLTHG UNTIL
WASHED/RINSED. GET MD. INGEST:KEEP VICTIM WARM & CALM. IF VICTIM
(SUPP DATA)
===================== Fire Fighting Measures =====================
Extinguishing Media:USE MEDIA AS APPROPRIATE FOR SITE SPECIFIC
CONDITIONS.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NO SPECIFIC DATA.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. CONTAIN AND CLEAN UP SPILL
USING ABSORBENT MATERIAL. ONCE ABSORBED, PLACE "SPENT ABSORBENT" IN
A SUITABLE CONTAINER AND CLOSE THE LID. HOLD THE MATERIAL FOR
APPROPRIATE DISPOSAL. ONCESPILL PICK UP IS COMPLETE, RINSE AREA
WITH WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE. STORE IN A
SEALED CONDITION. USE GOOD LABORATORY TECHNIQUE WHEN HANDLING
PRODUCT.
Other Precautions:DO NOT MOUTH PIPETTE. OBSERVE APPROPRIATE CHEMICAL
HYGIENE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED WHERE ADEQUATE VENTILATION
CONDITIONS EXIST. NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:USE ADEQUATE GENERAL ROOM VENTILATION.
Other Protective Equipment:EYE WASH AND DELUGE SHOWER. LAB COAT.
Work Hygienic Practices:UPON COMPLETION OF WORK ACTIVITIES INVOLVING
PRODUCT, WASH ANY EXPOSED BODY AREAS THORO W/SOAP & WATER. DO NOT
(SUPDAT)
Supplemental Safety and Health
MFR PT#/TRADE NAME:ANALYZERS, 082063700. FIRST AID PROC:IS ABLE, GIVE
LARGE AMOUNTS OF WATER. GET MD. INHAL:MOVE TO FRESH AIR. IF
BREATHING IS LABORED, GIVE OXYGEN. IF BREATHING STOPS, GIVE
ARTIFICIA L RESPIRATION. GET MD IMMEDIATELY. HYGIENE PRACT:EAT,
DRINK OR SMOKE WHILE WORKING WITH THESE REAGENTS.
================== Physical/Chemical Properties ==================
Solubility in Water:SOLUBLE
Appearance and Odor:AQUEOUS SOLUTION
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
BORIC ACID IS INCOMPATIBLE WITH ALKALI CARBONATES AND HYDROXIDES.
Stability Condition to Avoid:EXCESS HEAT, FLAMES OR PRESSURE.
Hazardous Decomposition Products:BORIC ACID DECOMPOSITION PRODUCTS
INCLUDE BORON OXDIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:40% ALCOHOLS,KETONES,& ESTERS
CAGE:51926
CAGE:51926
CAGE:12204
============= Composition/Information on Ingredients =============
Ingred Name:ALCOHOLS
Ingred Name:KETONES
Ingred Name:ESTERS
===================== Hazards Identification =====================
Effects of Overexposure:DIZZINESS,SUFFOCATION,CONTACT W/LIQ.MAY CAUSE
BURNS TO SKIN & EYES
======================= First Aid Measures =======================
First Aid:REMOVE TO FRESH AIR.CALL DOCTOR.IF NOT BREATHING GIVE
ARTIFICIAL RESPIRATION.IF BREATHING IS DIFFICULT GIVE OXYGEN.IN
CASE OF CONTACT W/MATERIAL IMMEDIATELY FLUSH SKIN OR EYES W/RUNNING
WATER FOR AT L EAST 15 MINS.REMOVE CONT.CLOTHING & SHOES
===================== Fire Fighting Measures =====================
Extinguishing Media:SML FIRES:DRY CHEMICAL OR CO*2.LG FIRES:WATER SPRAY
OR FOG.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS
Unusual Fire/Explosion Hazard:MAY BE IGNITED BY
HEAT,SPARKS,FLAMES.FLAMM.VAPORS MAY SPREAD.CONTS MAY EXPLODE IN HT
OF FIRE,GAS EXP
================== Accidental Release Measures ==================
Spill Release Procedures:NO FLARES,SMOKING OR FLAMES IN HAZARD
AREA.STOP LEAK IF W/O RISK.USE WATER SPRAY TO REDUCE VAPORS.DO NOT
TOUCH SPILLED LIQUID.ISOLATE AREA UNTIL GAS HAS DISPERSED
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY ROM ALL POSSIBLE SOURCES OF
IGNITION & COMBUSTIBLE MATERIALS.ISOLATE FRM
EXPLOSIVES,TOXICANTS,RADIOACTIVE MATERIALS,ORG.PEROXIDES.
Other Precautions:KEEP AWAY ROM CHLORINE BROMINE,FLUORINE,COPPER,SILVE
OR MERCURY.PROTECT AGAINST LIGHTNING,&STATIC
ELECTRICITY.PRECAUTIONS SHOULD BE TAKEN TO PRECLUDE ELECTRICAL
CHARGES FROM OCCURING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SELF-CONTAINED BREATHING APPARATUS
Ventilation:AS REQUIRED TO CONTROL VAPORS IN AIR
Supplemental Safety and Health
ITEM I A 40% MIXTURE OF ALCOHOLS,KETONES,AND ESTERS;FOR FURTHER
INFORMATION ABOUT THIS ITEM I,CONTACT CHEMICAL
================== Physical/Chemical Properties ==================
HCC:V3
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
COMBUSTIBLES,IGNITION SOURCES,EXPLOSIVES,TOXICANTS,PEOXIDES
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE UNDER CONTROLLED CONDITIONS OR PLACE
IN APPROVED STORAGE CONTAINERS & SHIP TO AN APPROVED DISPOSAL AREA
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ENAMEL ALKYD GLOSS GREEN 14064
CAGE:0LV01
CAGE:61196
CAGE:0LV01
============= Composition/Information on Ingredients =============
Ingred Name:*MINERAL SPIRITS
CAS:64475-85-0
RTECS #:PY8240000
ACGIH TLV:100PPM
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:IRON OXIDE
CAS:1332-37-2
RTECS #:NO7380000
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3; 9192
===================== Hazards Identification =====================
Effects of Overexposure:MATRL INTO LUNGS CAN CAUSE CHEM PNEUMONITIS
WHICH CAN BE FATAL.INHAL:NAUSEA,UNCONSCIOUS,EVN ASPHYXIA
======================= First Aid Measures =======================
First Aid:SWALLOWED:INDUC VOMIT IMMED.GIVNG 2 GLASES OF WATER &
STICKING FINGER DOWN THROAT.CONSULT DR OR POISON CONTROL CENTR
IMMED.(NVR GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS
PERSON.)INHAL:REMOV TO FRESH AI R IMMED.IF BREATH HAS STOP,GIVE
ARTIF RESPIRATION
===================== Fire Fighting Measures =====================
Flash Point:80F,27C
Extinguishing Media:CL B FIRE EXTING(CO*2,ALL PURPOS DRY CHEM OR ALCOH
FOAM)
Fire Fighting Procedures:FIREFIGHTERS SHOULD WEAR SELF-CONTND BREATHING
APPARATUS.
Unusual Fire/Explosion Hazard:KP CONTNRS TIGHTLY CLOS.ISOLAT FR
HEAT,ELECT EQPMT,SPARKS & FLAME CLOS CONTNRS MAY EXPLOD EXPOS(SUP)
================== Accidental Release Measures ==================
Spill Release Procedures:KEEP SPECTATORS AWAY.ELIM ALL IGNIT SOURCES
(FLAMES,HOT SURFACES & SOURCES OF ELECTR,STATIC OR FRICTIONAL
SPARKS).DIKE & CONTN SPILL W/INERT MATRL (E.G.SAND,EARTH).TRANSFER
LIQDS TO COVERED METAL CONT NRS F/RECOVERY OR DISPOS,OR REMOV
INERTABSOBR.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 120F.STORE LG
QUANTITIES IN COMPLIANCE W/OSHA 29CFR1910.106.
Other Precautions:DO NOT TAKE INTERNALLY.CLOSE CONTNR AFTER EACH USE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPRVD MECH FILTR RESPIR TO REMOV
OVRSPRAY.
Ventilation:PROVID GEN DILUT & LOC EXHAUST VENTIL IN SUFFICIENT VOLUME
Other Protective Equipment:NOT LIKELY TO BE NEEDED.
Supplemental Safety and Health
*INDICATES SOLVENT. UNUS. FIRE & EXPLOS. HAZ: TO EXTREME HEAT.
HAZARDOUS DECOMP PRODUCTS: AND CO*2.
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:193-395F
Vapor Density:HEAV
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:61
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS OR ALKALINE MATERIALS
Stability Condition to Avoid:NONE KNOWN
Hazardous Decomposition Products:BURNING,INCLD WHN HEAT BY
WELD,CUTTNG,WILL PRODUC SMOK CO(SU
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOS IN ACCORD W/FED,STATE & LOC
LAWS.INCINERATE ONLY IN EPA PERMITTED FACILITY.DO NOT INCIN CLOS
CONTNRS.OBSERV PRECAUTIONS F/DISPOS OF FLAMMBL MATRLS.CONTAMINATED
ABSORBANT MAY BE DISPOS IN A HAZ WASTE LANDFILL.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CARB MEDIC CARBURATOR CHOKE & VALVE CLEANER,M 48-14
CAGE:77628
CAGE:0X818
CAGE:00WU8
CAGE:77628
============= Composition/Information on Ingredients =============
Ingred Name:TOLUENE (SARA 313) (CERCLA)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 20 - 50%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:200 PPM; Z-2
ACGIH TLV:S, 50 PPM; 9596
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:XYLENES (O-,M-,P- ISOMERS) (SARA 313) (CERCLA)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 0 - 20%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/150STEL;9596
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:METHYLENE CHLORIDE (SARA 313) (CERCLA)
CAS:75-09-2
RTECS #:PA8050000
Fraction by Wt: 25 - 35%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:500 PPM; Z-2
ACGIH TLV:50 PPM, A2; 9596
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:METHYL ALCOHOL (METHANOL) (SARA 313) (CERCLA)
CAS:67-56-1
RTECS #:PC1400000
Fraction by Wt: 10 - 30%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:S, 200 PPM
ACGIH TLV:S,200PPM/250STEL; 96
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ACETONE (SARA 313) (CERCLA)
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 0 - 20%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1000 PPM
ACGIH TLV:750PPM/1000STEL;9596
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:KETONES
Fraction by Wt: 0 - 20%
Other REC Limits:NONE RECOMMENDED
Ingred Name:ALCOHOLS
Fraction by Wt: 0 - 20%
Other REC Limits:NONE RECOMMENDED
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 10 - 15%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT; 9596
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT) IS NOT KNOWN.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYE, SKIN, CNS,
RESPIRATORY TRACT. ACUTE- TOXIC. INHALATION MAY CAUSE CNS EFFECTS.
MAY CAUSE SEVERE EYE IRRITATION. PROLONGED SKIN CONTACT MAY CAUSE
IRRITATION & DEFATTING. INGESTION IS UNLIKELY (AEROSOL). IF
SWALLOWED, CAN CAUSE VOMITING, GI IRRITATION, DIARRHEA, BLINDNESS &
DEATH. CHRONIC- UNKNOWN.
Explanation of Carcinogenicity:CONTAINS METHYLENE CHLORIDE.
Effects of Overexposure:IRRITATION, HEADACHE, DIFFICULTY IN BREATHING,
NAUSEA, VOMITING, DEFATTING, DIZZINESS, LOSS OF COORDINATION,
FATIGUE, CONFUSION, DERMATITIS, BLURRED VISION, TEARING, BLINDNESS,
DIARRHEA, DEATH
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH PRE-EXISTING
DISEASES OF THE EYE, SKIN, RESPIRATORY TRACT, CNS MAY HAVE
INCREASED SUSCEPTIBILITY TO THE TOXICITY OF EXCESSIVE EXPOSURES.
======================= First Aid Measures =======================
First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALED:MOVE TO FRESH
AIR. PROVIDE CPR/OXYGEN IF NEEDED. EYES:FLUSH WITH WATER FOR 15
MINUTES, HOLDING EYELIDS OPEN. SKIN:WASH WITH SOAP & WATER. ORAL:DO
NOT INDU CE VOMITING. SEEK IMMEDIATE MEDICAL ATTENTION. IF
SPONTANEOUS VOMITING OCCURS, KEEP HEAD BELOW HIPS TO PREVENT
ASPIRATION OF VOMITUS INTO LUNGS.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:FLAMMABL AEROSOL
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE (CO2), ALCOHOL FOAM
OR DRY CHEMICAL. USE WATER SPRAY TO COOL FIRE EXPOSED CONTAINERS.
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS OPERATED IN POSITIVE PRESSURE
MODE.
Unusual Fire/Explosion Hazard:SPRAY CANS UNDER PRESSURE. EXTREMELY
FLAMMABLE. EXPLOSION HAZARD EXISTS WHEN SPRAY CANS HEATED. DO NOT
ENTER SPRAY CAN STORAGE AREA IF FIRE PRESENT.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. REMOVE IGNITION SOURCES.
LEAKING CONTAINERS SHOULD BE PLACED OUTDOORS, IN AN OPEN CONTAINER,
AWAY FROM SOURCES OF IGNITION. ALLOW PRESSURE TO DISSIPATE. ABSORB
LIQUID WITH NON-FLAMMABL E ABSORBENT AND PLACE IN CONTAINER FOR
DISPOSAL.
Neutralizing Agent:NOT RELEVANT
======================Handling and Storage ======================
Handling and Storage Precautions:STORE SPRAY CANS IN COOL, WELL
VENTILATED AREAS AWAY FROM SOURCES OF IGNITION, STRONG OXIDIZING
AGENTS & SUNLIGHT. DO NOT STORE ABOVE 120F.
Other Precautions:"EMPTY" CONTAINERS RETAIN RESIDUE AND MAY BE
DANGEROUS. FOLLOW ALL LABEL INSTRUCTIONS. AVOID REPEATED/PROLONGED
SKIN CONTACT. KEEP OUT OF REACH OF CHILDREN. DO NOT BREATHE VAPORS.
DO NOT SPRAY TOWARD FACE/HOT SURFACES. WASH AFTER HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF TLV IS EXCEEDED, WEAR NIOSH-APPROVED ORGANIC
VAPOR RESPIRATOR OR AIR-PURIFYING RESPIRATOR. IN EMERGENCY, WEAR A
NIOSH-APPROVED POSITIVE-PRESSURE SELF-CONTAINED BREATHING
APPARATUS.
Ventilation:MECHANICAL (GENERAL AND/OR LOCAL EXHAUST, EXPLOSION-PROOF)
VENTILATION TO MAINTAIN EXPOSURE BELOW TLV(S).
Other Protective Equipment:EYE WASH STATION & SAFETY SHOWERS SHOULD BE
AVAILABLE IN THE IMMEDIATE VICINITY OF ANY POTENTIAL EXPOSURE.
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. WASH THOROUGHLY BEFORE EATING,
DRINKING/SMOKING.
Supplemental Safety and Health
FORMULA CHANGED. FOR PREVIOUS FORMULATIONS, SEE PNI A-E, SAME NSN.
EXTREMELY FLAMMABLE. CONTENTS UNDER PRESSURE. CONTAINS FLAMMABLE
GAS SUCH AS PROPANE AND FLAMMABLE LIQUID. DO NOT USE IN CONFINED
ARE A OR AREA WITH LITTLE AIR MOVEMENT. EMPLOY MEANS TO PREVENT
VAPOR BUILDUP.
================== Physical/Chemical Properties ==================
HCC:V3
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:-44F - 231F
Spec Gravity:0.85
Viscosity:NOT KNOWN
Solubility in Water:SLIGHT
Appearance and Odor:CLEAR TO PALE LIQUID - CHARACTERISTIC ODOR
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES, DIRECT SUNLIGHT,
TEMPERATURES ABOVE 120F
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
CHLORINE, HYDROGEN CHLORIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. DO NOT PUNCTURE, INCINERATE SPRAY CANS EVEN
AFTER USE. DO NOT FLUSH INTO DRAINS. CONTRACT WITH APPROVED WASTE
DISPOSAL FACILITY CAPA BLE OF HANDLING FLAMMABLE AEROSOLS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:WESGO METAL PRODUCTS & ALLOYS CORROWNIBSI AMS-4783!
CAGE:WESGO
CAGE:WESGO
============= Composition/Information on Ingredients =============
Ingred Name:TUNGSTEN (INSOLUBLE), WOLFRAM
CAS:7440-33-7
RTECS #:YO7175000
Fraction by Wt: 4%
OSHA PEL:5 MG/CUM
ACGIH TLV:5 MG/CUM
Ingred Name:BORON
CAS:7440-42-8
RTECS #:ED7350000
Fraction by Wt: 0.8%
Ingred Name:COBALT
CAS:7440-48-4
RTECS #:GF8750000
Fraction by Wt: BALANCE
Other REC Limits:0.05 PPM
OSHA PEL:0.1 MG/M3;AS CO
ACGIH TLV:0.05 MG/M3;DUST 9293
Ingred Name:CHROMIUM METAL, CHROMIUM, CHROME (SUSPECTED A1 HUMAN
CARCINOGEN BY IARC, NTP & ACGIH)
CAS:7440-47-3
RTECS #:GB4200000
Fraction by Wt: 19%
OSHA PEL:1 MG/CUM
ACGIH TLV:0.5 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:NICKEL (SOLUBLE)
INTENDED CHANGE (IC)
CAS:7440-02-0
RTECS #:QR5950000
Fraction by Wt: 17%
Other REC Limits:1 MG/CUM
OSHA PEL:1 MG/CUM
ACGIH TLV:0.05 MG/CUM IC (A1)
Ingred Name:SILICON
CAS:7440-21-3
RTECS #:VW0400000
Fraction by Wt: 8%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION/DISCOLORATION. SKIN:
IRRITATION/ALLERGIC REACTION/RASH/DERMATITIS/DISCOLORATION.
INHALATION: NOSE/THROAT IRRITATION/SENSITIZED RESPIRATORY
DISEASE/COUGH/SHORTNESS OF BREATH/NERVOUS SY STEM
EFFECTS/WALKING/BALANCING DIFFICULTY/WEAKNESS/CRAMPS IN
LEGS/HOARSENSS OF VOICE/MEMORY/JUDGMENT TROUBLE.
Explanation of Carcinogenicity:CHROMIUM IS A SUSPECTED A1 HUMAN
CARCINOGEN BY ACGIH.
Effects of Overexposure:INHALATION: BENIGN PNEUMOCONIOSIS CALLED
STANNOSIS, MUCOUS MEMBRANE DISCOLORATION, UNSTABLE EMOTIONS,
PNEUMONIA-LIKE ILLNESS. COPPER MAY PRODUCE KERATINIZATION OF
HANDS/SOLES OF FEET. COBALT MAY PRODU CE PERMANENT DISABILITY OR
DEATH. BORONMAY PRODUCE SHOCK/COMA. TITANIUM MAY PRODUCE LUNG
FIBROSIS/CHRONIC BRONCHITIS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. SUPPORT RESPIRATION AS
NEEDED. SKIN: WASH W/MILD DETERGENT & WATER. EYES: FLUSH W/WATER
FOR AT LEAST 15 MINS. INGESTION: OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:DON'T USE WATER USE DRY CHEMICAL, SAND OR OTHER
APPROPRIATE EXTINGUISHING AGENT FOR SURROUNDING FIRE
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:MAY OCCUR W/CERTAIN METAL DUST FIRES.
================== Accidental Release Measures ==================
Spill Release Procedures:USE NORMAL CLEAN-UP PROCEDURES USING WET
SWEEPING OR VACUUM, TAKING CARE TO AVOID EXCESSIVE DUSTING.
======================Handling and Storage ======================
Other Precautions:AVOID DUST INHALATION & CONTACT OF MATERIALS W/EYES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED RESPIRATOR WHEN AIRBORNE DUST
CONCENTRATIONS >PEL/TLV.
Ventilation:SUFFICIENT GENERAL & LOCAL EXHAUST TO KEEP <PEL/TLV
Other Protective Equipment:EYEWASH FOUNTAIN
Work Hygienic Practices:MAINTAIN GOOD HOUSEKEEPING TECHNIQUES SUCH AS
WET SWEEPING OR VACUUMING TO REMOVE DUST ACCUMULATION
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:842-3272F
Spec Gravity:6-9
Solubility in Water:INSOLUBLE
Appearance and Odor:SOLID METAL OR POWDER W/NO ODOR
Percent Volatiles by Volume:0%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS, STRONG OXIDIZERS, STRONG BASES, & MOISTURE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:91-4 SODIUM NITRITE SOLUTION
Kit Part:Y
CAGE:21076
CAGE:21076
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM NITRITE *97-4*
CAS:7632-00-0
RTECS #:RA1225000
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(RAT): 180 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY BE HARMFUL BY INHALATION,
INGESTION/SKIN ABSORPTION. EYES/SKIN: IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION.
======================= First Aid Measures =======================
First Aid:INGESTION: WASH OUT MOUTH W/WATER IF CONSCIOUS. SKIN: FLUSH
W/COPIOUS AMOUNTS OF WATER FOR 15 MINS. INHALATION: REMOVE TO FRESH
AIR. EYES: FLUSH W/COPIOUS AMOUNTS OF WATER FOR 15 MINS. OBTAIN
MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE EXTINGUISHING MEDIA APPROPRIATE TO SURROUNDING
FIRE CONDITIONS.
Fire Fighting Procedures:WEAR SCBA & PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:NONCOMBUSTIBLE.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. ABSORB ON
SAND/VERMICULITE & PLACE IN CLOSED CONTAINERS FOR DISPOSAL.
VENTILATE AREA & WASH SITE AFTER MATERIAL PICKUP IS COMPLETE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR APPROPRIATE NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:MECHANICAL EXHAUST REQUIRED.
Other Protective Equipment:PROTECTIVE CLOTHING.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING & SHOES
BEFORE REUSE.
Supplemental Safety and Health
THIS MSDS IS FOR A-NAPHTHYL ACETATE ESTERASE KIT.
================== Physical/Chemical Properties ==================
Appearance and Odor:LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISSOLVE/MIX W/A COMBUSTIBLE SOLVENT & BURN IN A
CHEMICAL INCINERATOR EQUIPPED W/AN AFTERBURNER & SCRUBBER,
IAW/FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:210S WATERBORNE UNDERCOATS
Preparer's Name:T R LOUER
CAGE:EO716
CAGE:90227
CAGE:EO716
============= Composition/Information on Ingredients =============
Ingred Name:METHANOL (METHYL ALCOHOL), COLUMBIAN SPIRITS *95-2*
CAS:67-56-1
RTECS #:PC1400000
Fraction by Wt: 2%
Other REC Limits:200 PPM
OSHA PEL:260 MG/CUM
ACGIH TLV:262 MG/CUM (SKIN)
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TITANIUM DIOXIDE, TIO2 (SUSPECTED ANIMAL CARCINOGEN, IARC
GROUP 3) *95-2*
CAS:13463-67-7
RTECS #:XR2275000
OSHA PEL:15 MG/CUM
ACGIH TLV:10 MG/CUM (DUST)
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Ingred Name:TALC (POWDER), (ASBESTOS FREE), TALCUM; HYDROUS MAGNESIUM
SILICATE
CAS:14807-96-6
RTECS #:WW2710000
ACGIH TLV:2 MG/CUM (RESP DUST)
Ingred Name:ACRYLIC POLYMER
Ingred Name:2-BUTOXYETHANOL (ETHYLENE GLYCOL MONOBUTYL ETHER), BUTYL
CELLOSOLVE, BUTYL GLYCOL, GLYCOL ETHER EB
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: 1%
Other REC Limits:25 PPM (SKIN)
OSHA PEL:50 PPM (SKIN)
ACGIH TLV:25 PPM (SKIN)
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: MAY CAUSE NOSE & THROAT
IRRITATION. REPEATED/PROLONGED OVEREXPOSURE TO SOLVENTS MAY LEAD TO
PERMANENT BRAIN & NERVOUS SYSTEM DAMAGE. SKIN: IRRITATION, BURNING
& DERMATITIS. EYES: IRRITATIO N & BURNING.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:GI DISTRESS, IRRITATION, EYE WATERING,
HEADACHES, NAUSEA, DIZZINESS, LOSS OF COORDINATION, BURNING,
DISCOMFORT.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. EYES: IMMEDIATELY FLUSH
W/PLENTY OF WATER FOR 15 MINS. SKIN: WASH W/SOAP & WATER. OBTAIN
MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:>100F
Lower Limits:0.9
Upper Limits:36.5
Extinguishing Media:WATER SPRAY, FOAM, CO2, DRY CHEMICAL
Fire Fighting Procedures:USE FULL PROTECTIVE EQUIPMENT & SELF CONTAINED
BREATHING APPARATUS. WATER FROM FOG NOZZLES MAY BE USED TO COOL
CLOSED CONTAINERS TO PREVENT PRESSURE BUILDUP.
Unusual Fire/Explosion Hazard:WHEN HEAT >FLASHPOINT, EMITS FLAMMABLE
VAPORS WHICH, WHEN MIXED W/AIR, CAN BURN/BE EXPLOSIVE. FINE
MISTS/SPRAYS MAY BE FLAMMABLE AT TEMPS 120F. CLOSE CONTAINER
AFTER EACH USE. KEEP AWAY FROM IGNITION SOURCES. GROUND CONTAINERS
WHEN POURING.
Other Precautions:DON'T SAND, FLAME CUT, BRAZE/WELD DRY COATING W/OUT A
NIOSH/MSHA APPROVED RESPIRATOR/APPROPRIATE VENTILATION. DON'T
BREATHE VAPORS/MISTS. PREVENT SKIN CONTACT. DON'T PERMIT ANYONE
W/OUT PROTECTION IN THE PAINTING AREA.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR A PROPERLY FITTED VAPOR/PARTICULATE
RESPIRATOR APPROVED BY NIOSH/MSHA FOR USE W/PAINTS DURING
APPLICATION & UNTIL ALL VAPORS & SPRAY MISTS ARE EXHAUSTED. IN
CONFINED SPACES, WEAR A POSITIVE-PRESS URE, SUPPLIED-AIR
RESPIRATOR.
Ventilation:SUFFICIENT IN VOLUME & PATTERN TO KEEP CONTAMINANTS BELOW
APPLICABLE OSHA REQUIREMENTS.
Other Protective Equipment:COVERALLS
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING & BEFORE
EATING/SMOKING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:145-509F
Vapor Density:>1
VOC Grams/Liter:1.5
Evaporation Rate & Reference:LESS THAN ETHER
Solubility in Water:MISCIBLE
Percent Volatiles by Volume:0-61
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HEAT, SPARKS, FLAME & OTHER IGNITION
SOURCES
Hazardous Decomposition Products:CO, CO2, SMOKE
==================== Disposal Considerations ====================
Waste Disposal Methods:DON'T INCINERATE IN CLOSED CONTAINERS.
INCINERATE ABSORBED MATERIAL IN ACCORDANCE W/LOCAL, STATE & FEDERAL
REGULATIONS. UN1263.
======================= Other Information =======================
| 1 | gloves_mandatory |
=======================================================
NIIN: 00-738-1672
Product ID: H-152
Cage: ALUMI
Box: 472
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 01634
Box: 472
Cage: 1JY13
Cage: ALUMI
Box: 472
Cage: 1T620
=======================================================
Item Description Information
=======================================================
Item Manager: S9G
Item Name: DESICCANT,ACTIVATED
Unit of Issue: DR
Quantitative Expression: 00000000100LB
UI Container Qty: 0
Type of Container: DRUM
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: ORAL LD50 (RAT) IS UNKNOWN
Route Of Entry Inds - Inhalation: YES
Skin: NO
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE: EYE, SKIN & RESPIRATORY TRACT IRRITATION. AVOID
PROLONGED BREATHING OF THE DUST OR CONTACT OF DUST WITH THE SKIN.
Explanation Of Carcinogenicity: THIS PRODUCT AND ITS COMPONENTS ARE NOT LISTED
ON THE IARC, NTP OR OSHA CARCINOGENS LISTS.
Signs And Symptions Of Overexposure: MAY CAUSE EYE, SKIN & RESPIRATORY
TRACT IRRITATION.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: EYES: IMMEDIATELY WASH FROM EYES WITH LARGE AMOUNTS OF WATER,
OCCASIONALLY LIFTING THE UPPER & LOWER EYE LIDS. IF IRRITATION OCCURS AND
PERSISTS, SEEK MEDICAL ATTENTION. SKIN: WASH WITH SOAP AND WATER . INGESTION:
MATERIAL WILL PASS THROUGHTHE BODY NORMALLY. INHALATION: REMOVE TO FRESH AIR.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: USE DRY CLEANUP PROCEDURES; AVOID DUSTING. COLLECT IN
CONTAINERS OR BAGS. IF REUSE OR RECYCLING IS NOT POSSIBLE, MATERIAL MAY BE
DISPOSED OF AT A SANITARY LANDFILL.
Neutralizing Agent: NONE REQUIRED
Waste Disposal Methods: IF REUSE OR RECYCLING IS NOT POSSIBLE, MATERIAL AS
SUPPLIED MAY BE DISPOSED OF IN A SANITARY LANDFILL. PRODUCT AS PROCURED IS
NOT FEDERALLY REGULATED AS A RCRA WASTE IF DISPOSED OF AS PROCURED. IF CON
TAMINATED W/ A WASTE MATERIAL,FOLLOW APPRP. REGS.
Handling And Storage Precautions: KEEP IN COOL, DRY LOCATION AWAY FROM
MOISTURE.
Other Precautions: TAKE APPROPRIATE PRECAUTIONARY MEASURES TO PREVENT POSSIBLE
SKIN OR EYE IRRITATION.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: NONE
Extinguishing Media: PRODUCT IS NON-FLAMMABLE. USE MEDIA APPROPRIATE FOR
SURROUNDING FIRE.
Fire Fighting Procedures: FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER SPRAY TO
COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard: NONE
=======================================================
Control Measures
=======================================================
Respiratory Protection: WEAR A PROPERLY FITTED NIOSH/MSHA APPROVED DUST
RESPIRATOR IF CONDITIONS ARE DUSTY.
Ventilation: MECHANICAL(GENERAL) VENTILATION IS USUALLY ADEQUATE TO MAINTAIN
DUST LEVELS BELOW TLV FOR NUISANCE DUST.
Other Protective Equipment: AS DICTATED BY THE TASK AT HAND.
Work Hygienic Practices: WASH THOROUGHLY AFTER USE AND BEFORE EATING, DRINKING
OR SMOKING. VACUUM UP ANY DUST. LAUNDER CLOTHING BEFORE REUSE.
Supplemental Safety and Health: WATER SOLUBILITY: INSOLUBLE; SOLUBLE IN CONC.
ACIDS & ALKALIES; PH: ABOUT 10 FOR A 20% SLURRY SOLUTION.
=======================================================
Physical/Chemical Properties
=======================================================
HCC: N1
M.P/F.P Text: 3700F/2038C
Decomp Text: UNKNOWN
Spec Gravity: 3.2
PH: SUPP**
Solubility in Water: INSOLUBLE (SEE SUPP)
Appearance and Odor: CRYSTALLINE OR GELLATINOUS GRANULES, PELLETS OR POWDER W/
AN OFF-WHITE COLOR.
Corrosion Rate: UNKNOWN
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: MOISTURE: PRODUCT REACTS W/ WATER TO GENERATE
HEAT.
Materials To Avoid: MAY REACT W/ HF & STRONG ACIDS OR ALKALI TO PRODUCE
HYDROGEN GAS.
Hazardous Decomposition Products: NONE
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
Transportation Information
=======================================================
Trans ID NO: 83649
Product ID: H-152
Review Date: 04/03/1990
Net Unit Weight: 100 LBS.
Multiple KIT Number: 0
Review IND: Y
Unit Of Issue: DR
Container QTY: 0
Type Of Container: DRUM
Additional Data: FIBER DRUM IAW MIL-D-723,TY 1,GR C.
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: ZZZ
DOT Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: ZZZ
IMO Proper Shipping Name: NOT REGULATED FOR THIS MODE OF TRANSPORTATION
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: ZZZ
IATA Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: ZZZ
AFI Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
HAZCOM Label
=======================================================
Product ID: H-152
Cage: ALUMI
Company Name: ALUMINUM COMPANY OF AMERICA
Street: 1501 ALCOA BUILDING
PO Box: 472
Zipcode: 15219
Label Required IND: Y
Date Of Label Review: 04/02/1990
Status Code: C
Label Date: 04/02/1990
Year Procured: 1989
Origination Code: F
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: None
Reactivity Hazard: Slight
Hazard And Precautions: ACUTE: EYE, SKIN & RESPIRATORY TRACT IRRITATION.
AVOID DUSTING CONDITIONS.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:DEXRON-II MULTI-PURPOSE TRANSMISSION/TRANSA
CAGE:33876
CAGE:33876
============= Composition/Information on Ingredients =============
Ingred Name:PETROLEUM OIL
CAS:64741-89-5
RTECS #:PY8041500
Other REC Limits:NONE RECOMMENDED
Ingred Name:REFINED HEAVY PARAFFINIC DISTILLATES
CAS:64741-88-4
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PROLONGED CONTACT MAY IRRITATE THE
SKIN. EXPOSURE TO FUMES, MISTS, IF GENERATED, MAY IRRIATTE THE EYES
AND UPPER RESPIRATORY TRACT.
Explanation of Carcinogenicity:NOT A CARCINOGEN.
Effects of Overexposure:EYE-MAY CAUSE BURNING, TEARING AND REDNESS.
SKIN-PROLONGED OR REPEATED SKIN CONATCT MAY CAUSE BURNING, REDNESS
AND DERMATITIS. INHALATION-MAY IRRITATE THE NOSE, THROAT AND UPPER
RESPIRATORY TRACT. ING ESTION-ACCIDENTALLY SWALLOWING CAN CAUSE
IRRITATION OF THE STOMACH AND INTESTINAL TRACT.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN CONDITIOND.
PRE-EXISTING RESPIRATORY CONDITIONS IF MISTS OR FUMES ARE
GENERATED.
======================= First Aid Measures =======================
First Aid:EYE-FLUSH THE EFFECTED EYE WITH WATER. IF IRRITATION
DEVELOPS, SEEK MEDICAL ATTENTION. SKIN-WIPE MATERIAL FROM SKIN.
THOROUGHLY WASH SKIN WITH SOAP & WATER. USE A WATERLESS CLEANER, IF
NEEDED. BREATHI NG-MOVE AWAY FROM EXPOSURE TO MISTS OR FUMES INTO
FRESH AIR. SWALLOWING-IF VICTIM IS CONSCIOUS AND ALERT, GIVE MILK
OR WATER TO DRINK. SEEK MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:>400F,>204C
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM, AND WATER
SPRAY. WATER SPRAY OR FOAM MAY CAUSE FROTHING.
Fire Fighting Procedures:WEAR PROTECTIVE EQUIPMENT & CLOTHING WHEN
FIGHTING FIRES. USE A SELF-CONTAINED BREATHING APPARATUS FOR FIRES
IN ENCLOSED SPACES, USE WATER SPRAY TO COOL CONTNRS
Unusual Fire/Explosion Hazard:THIS MATERIAL CAN IGNITE & BURN WHEN
HEATED ABOVE ITS FLASH POINT. EMPTY TANKS OR CONTAINERS RETAIN
MATERIAL RESIDUE AND MAY, IF HEATED, CAN IGNITE & EXPLODE.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR RECOMMENDED PROTECTIVE CLOTHING &
EQUIPMENT & PROVIDE ADEQUATE VENTILATION. DO NOT ALLOW SPILLS TO
ENTER SEWERS, STREAMS OR SURFACE WATERS. DIKE & CONTAIN SPILL. PICK
UP LARGE SPILLS FOR LATER RE CLAMATION & DISPOSAL. USE AN INERT
ABSORBENT.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN CLOSED CONTAINERS IN A COOL,
DRY, WELL-VENTILATED AREA AWAY FROM HEAT AND STRONG OXIDIZING
AGENTS. PROTECT CONTAINERS FROM PHYSICAL DAMAGE.
Other Precautions:OPERATIONS SUCH AS MAINTENANCE, REPAIR, CLEAN-UP, OR
SAMPLING INCREASE THE POTENTIAL FOR EXPOSURE TO THIS MATERIAL.
PERSONNEL INVOLVED IN THESE TYPES OF OPERATIONS SHOULD WEAR
PROTECTIVE EQUIPMENT & C LOTHING & EXERCISE SPECIAL PRECAUTIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESPIRATORY PROTECTION MAY BE NECESSARY TO
MINIMIZE EXPOSURE TO MISTS & FUMES. WEAR A NIOSH-APPROVED
PARTICULATE RESPIRATOR IN SITUATIONS WHERE MIST CONCENTRATIONS MAY
EXCEED RECOMMENDED EXPOSURE LIMI TS.
Ventilation:GENERAL MECHANICAL VENTILATION OR LOCAL EXHAUST IS
RECOMMENDED TO MAINTAIN MIST OR FUME CONCENTRATIONS BELOW LIMITS.
Other Protective Equipment:PROTECTIVE CLOTHING ARE RECOMMENDED TO
PREVENT SKIN CONTACT. USE BARRIER CREAMS SPECIFIC FOR
PETROLEUM-BASED MATERIAL.
Work Hygienic Practices:AN EYE WASH & A SOURCE OF RUNNING WATER SHOULD
BE AVAILABLE TO FLUSH OR WASH THE EYES AND SKIN.
Supplemental Safety and Health
USE SELF-CONTAINED SUPPLIED-AIR RESPIRATORS FOR EMERGENCIES.
================== Physical/Chemical Properties ==================
HCC:V6
Boiling Pt:B.P. Text:>600F,>316C
Melt/Freeze Pt:M.P/F.P Text:NA
Decomp Temp:Decomp Text:NA
Vapor Pres:NEGLIGIBLE
Vapor Density:>AIR
Spec Gravity:0.85-0.95
pH:NA
Viscosity:>100 SUS
Evaporation Rate & Reference:NEGLIGIBLE
Solubility in Water:NEGLIGIBLE
Appearance and Odor:A RED COLORED OILY LIQUID WITH A PAINT PETROLEUM
ODOR.
Percent Volatiles by Volume:NEGL
Corrosion Rate:NA
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
INCOMPATIBLE WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:BURNING PRODUCES CARBON DIOXIDE,
CARBON MONOXIDE & POSSIBLE TRACE AMOUNTS OF OXIDES OF SULFUR AND
NITROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE AND
LOCAL REGULATIONS. EMPTY TANKS & CONTAINERS SHOULD BE COMMERCIALLY
CLEANED AND RECONDITIONED BEFORE REUSE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CLEAR LIQUID WITH RED TUBING AMPOULE 5 PSN
Kit Part:Y
Preparer's Name:HMIS TECHNICIAN
CAGE:7W168
CAGE:7W168
============= Composition/Information on Ingredients =============
Ingred Name:POTASSIUM CARBONATE
CAS:584-08-7
RTECS #:TS7750000
Other REC Limits:NONE SPECIFIED
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE BURNS OR IRRITATION OF SKIN
AND EYES ON CONTACT. MAY IRRITATE RESPIRATORY TRACT IF INHALED. MAY
CAUSE GI TRACT IRRITATION IF SWALLOWED.
Explanation of Carcinogenicity:NO INGREDIENT WITH A CONCENTRATION OF
0.1% OR GREATER IS LISTED AS A CARCINOGEN OR SUSPECTED CARCINOGEN.
Effects of Overexposure:INHALATION: COUGHING, SNEEZING. EYES: REDNESS,
PAIN, TEARS. SKIN: REDNESS, PAIN, ITCHING. INGESTION: BURNS AROUND
MOUTH AND THROAT, STOMACH PAIN, NAUSEA, VOMITNG.
======================= First Aid Measures =======================
First Aid:INHALED:REMOVE TO FRESH AIR. EYE:IMMEDIATELY FLUSH WITH
PLENTY OF WATER FOR 15 MINUTES. SEE DOCTOR. SKIN: WASH WITH SOAP
AND WATER. REMOVE CONTAMINATED CLOTHING & SHOES. INGESTED: INDUCE
VOMITING. REP EAT UNTIL VOMIT IS CLEAR. NOTHING BY MOUTH IF
UNCONSCIOUS. GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Extinguishing Media:EXTINGUISH WITH AGENT SUITABLE FOR SURROUNDING FIRE
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE GEAR.
Unusual Fire/Explosion Hazard:NONE KNOWN
================== Accidental Release Measures ==================
Spill Release Procedures:ISOLATE THE SPILLED MATERIAL. DILUTE WITH
SUFFICIENT WATER. MIX AND NEUTRALIZE WITH 5% ACETIC ACID.
Neutralizing Agent:5% ACETIC ACID.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR IF
ENGINEERING CONTROLS UNAVAILABLE OR INSUFFICIENT. IF USED; DO SO IN
ACCORDANCE WITH 29 CFR 1910.134.
Ventilation:USE ADEQUATE MECHANICAL VENTILATION.
Other Protective Equipment:EYE WASH STATION & SAFETY SHOWER
Work Hygienic Practices:WASH HANDS AFTER USE AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health
KEY1:B3. MANUFACTURER OUT OF BUSINESS/MSDS UNAVAILABLE. MSDS GENERATED
BY HMIS TECHNICIAN UTILIZING ANOTHER MANUFACTURER'S MSDS, CHEMICAL
DEFENSE EQUIPMENT DISPOSAL DATA AND SAX/ALDRICH.
================== Physical/Chemical Properties ==================
HCC:F5
Evaporation Rate & Reference:>1
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR,WATER-WHITE SOLUTION
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
KCO,CLF3,MG
Stability Condition to Avoid:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SOLVENT BLEND T 81772 TYPE 2 REV
CAGE:5A188
CAGE:5A188
============= Composition/Information on Ingredients =============
Ingred Name:METHYL ISOBUTYL KETONE (SARA 313)
CAS:108-10-1
RTECS #:SA9275000
Fraction by Wt: 35%
Other REC Limits:NIOSH 50 PPM TWA
OSHA PEL:100 PPM/75 STEL
ACGIH TLV:50 PPM/75 STEL; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:PROPYLENE GLYCOL MONOMETHYL ETHER
CAS:107-98-2
RTECS #:UB7700000
Fraction by Wt: 65%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/150 PPM STEL
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION. SKIN: MODERATE
IRRITATION, DEFATTING, DERMATITIS. BREATHING: NASAL, RESP
IRRITATION, CENTRAL NERVOUS SYSTEM EFFECTS, DEATH. SWALLOWING:
GASTROINTESTINAL IRRITATION. OVEREXPOSURE TO M ATERIAL (OR
COMPONENTS) HAS BEEN FOUND TO CAUSE (LAB ANIMAL) FOLLOWING: LIVER
ABNORMALITIES, KIDNEY, LUNG, BRAIN DAMAGE.
Effects of Overexposure:EYES: REDNESS, TEARING. BREATHING: CENTRAL
NERVOUS SYSTEM EFFECTS: WEAKNESS, FATIGUE, NAUSEA, HEADACHE AND
POSSIBLE UNCONSCIOUSNESS. SWALLOWING NAUSEA, VOMITING, DIARRHEA.
======================= First Aid Measures =======================
First Aid:SKIN: WASH W/SOAP & WATER. REMOVE CONTAM CLOTH. EYES: FLUSH
W/LRG AMT WATER, LIFT EYELIDS OCCASION, GET MED ATTN. INGEST: DON'T
INDUCE VOMIT, KEEP PERSON WARM, QUIET, GET MED ATTN. ASPIRATION
(MATERIA L INTO LUNGS--VOMIT) CAN CAUSE CHEM PNEUMONITIS (CAN BE
FATAL). INHAL: REMOVE TO FRESH AIR. IF BREATHING DIFFICULT, ADMIN
OXYGEN. IF BREATHING STOPPED GIVE ARTIF RESP. KEEP WARM, QUIET, GET
MED AID.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:55.0 TO 65.0F
Lower Limits:1.4
Extinguishing Media:REGULAR FOAM, OR CARBON DIOXIDE OR DRY CHEMICAL. @
760.00 MM HG. LOWEST VALUE OF COMPONENT IS LISTED FOR MIX.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS WITH
FULL FACEPIECE OPERATED IN POSITIVE PRESSURE DEMAND MODE WHEN
FIGHTING FIRES. @ 68F. HIGHEST VALUE.
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR, MAY TRAVEL
ALONG GROUND OR MOVED BY VENT & IGNITED BY PILOT LIGHT, FLAME,
SPARK, HEATER, SMOKING, ELEC MOTOR, STATIC, IGNIT SOURCE.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL: ABSORB LIQ ON ABSORBENT. LARGE: ELIMIN
IGNIT SOURCE. EVAC UNPROTECTED. STOP SPILL. DIKE SPILL, PUMP TO
SALV TANK. REMAINING MAY BE TAKEN UP ON ABSORB. SHOVEL INTO CNTNRS.
PREVENT RUNOFF TO SEWE R/STREAM/WATER BODY. NOTIFY AUTHORITIESOF
SPILL.
======================Handling and Storage ======================
Handling and Storage Precautions:CNTNRS OF MAT'L MAY BE HAZARDOUS WHEN
EMPTIED. SINCE EMPTIED CNTNRS RETAIN PRODUCT RESIDUES, OBSERVE ALL
HAZARD PRECAUTIONS GIVEN IN THIS DATASHEET.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF TLV/PEL OF PRODUCT/COMPNENT EXCEEDED, NIOSH/
MSHA AIR SUPPLIED RSPRTR ADVISED IN ABSENCE OF ENVIRONMNTL CONTROL.
OSHA REGS PERMIT NIOSH/MSHA RSPRTRS (NEG PRESS TYPE) UNDER
SPECIFIED COND. IMPLEMENT ENGINEERING/ADMINISTRATION CONTROLS.
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL/LOCAL EXHAUST) VENT
TO MAINTAIN EXPOSURE BELOW TLV(S).
Other Protective Equipment:TO PREVENT REPEATED OR PROLONGED SKIN
CONTACT, WEAR IMPERVIOUS CLOTHING AND BOOTS.
Work Hygienic Practices:WASH CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:237F,114C
Vapor Pres:16. @68F
Spec Gravity:<1 @ 77F(WTR=1)
Evaporation Rate & Reference:SLOWER THAN ETHER.
Percent Volatiles by Volume:100.00
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
VARIOUS HYDROCARBONS, ETC.
==================== Disposal Considerations ====================
Waste Disposal Methods:SMALL SPILL: DISPOSE OF IN ACCORDANCE WITH ALL
LOCAL, STATE AND FEDERAL REGULATIONS. LARGE SPILL: DISPOSE OF IN
ACCORDANCE WITH ALL LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CAT, MIL-C-83286, 34088, 03GN040CAT
Kit Part:Y
Preparer's Name:NORM GAUL
CAGE:33461
CAGE:33461
============= Composition/Information on Ingredients =============
Ingred Name:ALIPHATIC ISOCYANATE (VAPOR PRESSURE: 0 MM HG)*
CAS:28182-81-2
Fraction by Wt: 30%
Other REC Limits:NONE SPECIFIED
Ingred Name:*HEXAMETHYLENE DIISOCYANATE (HDI) (CAS 822-06-0) FREE
MONOMER CONTENT LESS THAN 0.7% BASED ON RESIN SOLIDS AT TIME OF**
RTECS #:9999999ZZ
Other REC Limits:NONE SPECIFIED
Ingred Name:**MANUFACTURE. AFTER 3-6 MO STORAGE, THE FREE MONOMER
CONTENT MAY RISE (MAX-1.6%). ACGIH HAS PROPOSED A TLV OF 0.005 ***
RTECS #:9999999ZZ
Other REC Limits:NONE SPECIFIED
Ingred Name:***PPM TWA IN THE NOTICE OF INTENDED CHANGES FOR 1987-88.
MOBAY RECOMMENDS A CEILING LEVEL OF 0.02 PPM.
RTECS #:9999999ZZ
Other REC Limits:NONE SPECIFIED
Ingred Name:N-BUTYL ACETATE (SARA III)
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: <5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:150 PPM/200 STEL
ACGIH TLV:150 PPM/200STEL;9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: <5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: <5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ETHYL 3-ETHOXYPROPIONATE (SARA 313) (VAPOR PRESSURE: .7 MM
HG)
CAS:763-69-9
RTECS #:UF3325000
Fraction by Wt: 5%
Other REC Limits:NONE SPECIFIED
Ingred Name:METHYL ISOBUTYL KETONE (SARA III)
CAS:108-10-1
RTECS #:SA9275000
Fraction by Wt: 10%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM/75 STEL
ACGIH TLV:50 PPM/75 STEL; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 45%
Other REC Limits:NONE SPECIFIED
OSHA PEL:200 PPM/300 STEL
ACGIH TLV:200 PPM/300STEL 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:VOC: 633 G/L
RTECS #:9999999VO
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: VAPORS IRRITATING TO EYES/NOSE/
THROAT. INHALATION: IRRITATION, ACUTE NERVOUS SYSTEM DEPRESSION.
CHRONIC: PROLONGED CONTACT WILL CAUSE DEFATTING ACTION. INGESTION:
IRRITATION. ASPIRATION CAN CA USE CHEMICAL PNEUMONITIS. AS A RESULT
OF PREVIOUS REPEATED OVEREXPOSURE OR SINGLE LARGE DOSE, CERTAIN
INDIVIDUALS WILL
Effects of Overexposure:INHAL: DIFFICULT BREATHING, HEADACHE,
DIZZINESS, STAGGERING GAIT, CONFUSION, UNCONSCIOUSNESS, COMA. SKIN:
IRRIT (SWELLING/REDNESS/RASH). EYES: REDNESS, TEARING, SWELLING
W/STINGING. SKIN: SWELL/REDNES S/RASH. PROLONG/REPEAT--MOD IRRIT,
DRYING, SKIN CRACKING. INGEST: VOMIT. IRRIT. CORROSIVE TO
MOUTH/STOMACH/DIGEST TRACT.
Medical Cond Aggravated by Exposure:ASTHMA AND ANY OTHER RESPIRATORY
DISORDERS. SKIN ALLERGIES, ECZEMA, AND DERMATITIS.
======================= First Aid Measures =======================
First Aid:INHALATION: MOVE TO FRESH AIR. RESTORE BREATHING. ASTHMATIC
TYPE SYMPTOMS MAY DEVELOP (IMMED/DELAYED BY SEVERAL HRS). GET MED
AID. SKIN: REMOVE CONTAM CLOTHING. WASH AREA W/SOAP & WATER. WASH
CONTAM C LOTHING BEFORE REUSE. EYES: FLUSH WITH LUKEWARM WATER (LOW
PRESSURE)--15 MIN, LIFTING UPPER/LOWER LIDS. GET MED AID.
INGESTION: DON'T INDUCE VOMIT. NOTHING BY MOUTH TO UNCONSCIOUS
PERSON. GET MED AID.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:24.0F,-4.4C
Lower Limits:1%
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:FULL FIRE FIGHT EQUIP W/SCBA & FULL PROTECT
CLOTH. USE WATER TO COOL CLOSED CNTNRS/PREVENT PRESSURE
BUILD-UP/AUTO IGNITE/EXPLOSION. HDI/IRRIT VAPORS GENERATED.
Unusual Fire/Explosion Hazard:KEEP FROM IGNITE SOURCES. CLOSED CNTNR
MAY EXPLODE W/HEAT. USE SPECIAL PRECAUTION W/APPLIC TO HOT SRFCS.
DURING EMERG COND, OVEREXPOS TO DECOMP PROD/HEALTH HZD.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE ALL NON-ESSENTIAL PERSONNEL. REMOVE
ALL SOURCES OF IGNITION (FLAME, SPARK SOURCES, HOT SURFACES).
VENTILATE AREA. CONTAIN AND REMOVE WITH INERT ABSORBENT AND
NON-SPARKING TOOLS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN BLDG IN COMPLIANCE W/OSHA
1910.106. AVOID HIGH TEMP, IGNITION SOURCES. STORE IN TIGHTLY
CLOSED CONTAINERS. STORE IN WELL VENT AREAS.
Other Precautions:KEEP CNTNRS TIGHT/UPRIGHT (PREVENT LEAKAGE). NO
PROLONGED BREATHING OF VAPORS/SPRAY MISTS. AVOID CONTACT
W/SKIN/EYES. DO NOT TAKE INTERNALLY. DO NOT HANDLE UNTIL THE SAFETY
PRECAUTIONS HAVE BEEN READ/ UNDERSTOOD. SMOKE ONLY IN SMOKING
AREAS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE ORGANIC VAPOR RESPIRATOR (AIR
PURIFYING/FRESH AIR). OBSERVE OSHA REGS (RESPIRATOR USE). PROVIDE
VENT (KEEP EXPOSURE LEVELS BELOW OSHA LIMITS). VAPOR PARTIC RSPRTR
(TC23C--NIOSH/MSHA) IF VAPOR LEVE LS BELOW 10 X EXPOSURE LIMITS.
Ventilation:EXHAUST VENT SUFFICIENT TO KEEP AIRBORNE CONC (SOLVENT/
POLYISOCYANATES/HDI) BELOW TLV'S. REMOVE ALL IGNITION SOURCES.
Other Protective Equipment:FACE SHIELDS. THE USE OF LONG SLEEVE AND
LONG LEG CLOTHING IS RECOMMENDED.
Work Hygienic Practices:REMOVE AND WASH CONTAMINATED CLOTHING BEFORE
REUSE. WASH HANDS BEFORE EATING, SMOKING OR USING WASHROOM.
Supplemental Safety and Health
DEVELOP ISOCYANATE SENSITIZATION WHICH WILL CAUSE THEM TO REACT TO A
LATER EXPOSURE OF ISOCYANATES LEVELS WELL BELOW THE TLV VALUE OF
ISOCYANATES.
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:175 TO 338F
Vapor Density:> AIR
Spec Gravity:0.90
Viscosity:*
Evaporation Rate & Reference:3.54 X N-BUTYL ACETATE
Solubility in Water:INSOLUBLE
Appearance and Odor:AMBER LIQUID WITH SOLVENT ODOR.
Percent Volatiles by Volume:76.8
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER, AMINES, STRONG BASES, ALCOHOLS, METAL COMPOUNDS AND SURFACE
ACTIVE MATERIALS.
Stability Condition to Avoid:CONTACT WITH MOISTURE, MATERIALS WHICH
REACT WITH ISOCYANATES AND HIGH TEMPERATURES.
Hazardous Decomposition Products:BY HIGH HEAT/TEMPERATURE: CARBON
MONOXIDE, CARBON DIOXIDE, AND OXIDES OF NITROGEN, TRACES OF HCN AND
HDI.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE MUST BE DISPOSED IN ACCORD W/FEDERAL,
STATE & LOCAL ENVIRONMENTAL CONTROL REGULATIONS. EMPTY CONTAINERS
MUST BE HANDLED W/CARE (PRODUCT RESIDUE/FLAMMABLE VAPOR). DON'T
INCINERATE CLOSED CNTNRS. EPA HAZARDOUS WASTE #: D001, F003, F005.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:538 RAM POLYESTER COLORS
CAGE:29431
CAGE:29431
============= Composition/Information on Ingredients =============
Ingred Name:CYCLOHEXANONE (SARA III)
CAS:108-94-1
RTECS #:GW1050000
Fraction by Wt: 8-9%
Other REC Limits:100PPM (SKIN) STEL
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:BUTYRIC ACID LACTONE, TETRAHYDRO-2-FURANONE, BLO
CAS:96-48-0
RTECS #:LU3500000
Fraction by Wt: 3-6%
ACGIH TLV:10 PPM
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 0.5-2.8%
Other REC Limits:100 PPM
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: IRRITATION & DAMAGE. SKIN:
IRRITATION, RED, & DRY. INHALATION: RESPIRATORY TRACT IRRITATION,
HEADACHE, DIZZINESS, NAUSEA, VOMITING, LOSS OF CONSCIOUSNESS,
KIDNEY, LIVER, & CENTRAL NERVOUS SYSTEM DAMAGE. INGESTION:
IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYE: IRRITATION & DAMAGE. SKIN: IRRITATION,
RED, & DRY. INHALATION: RESPIRATORY TRACT IRRITATION, HEADACHE,
DIZZINESS, NAUSEA, VOMITING, LOSS OF CONSCIOUSNESS, KIDNEY, LIVER,
& CENTRAL NERVOUS SYSTEM DAMAGE. INGESTION: IRRITATION.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MINS. SKIN:
WASH THOROUGHLY W/SOAP & WATER. INHALATION: REMOVE TO FRESH AIR.
GIVE CPR IF NEEDED. INGESTION: INDUCE VOMITING. OBTAIN MEDICAL
ATTENTION IN A LL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:111F
Lower Limits:1%
Upper Limits:6.9%
Extinguishing Media:WATER FOG, ALCOHOL FOAM, CO2, & DRY CHEMICAL.
Fire Fighting Procedures:USE SELF-CONTAINED BREATHING APPARATUS. USE
WATER FOG TO COOL CONTAINERS.
Unusual Fire/Explosion Hazard:VAPOR IS >AIR, IT MAY TRAVEL & IGNITE OR
FLASHBACK. EMPTY CONTAINERS STILL COULD IGNITE EXPLOSIVELY. KEEP
AREA CLEAR OF SOURCES OF IGNITION.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB W/SAND. REMOVE ALL SOURCES OF IGNITION.
DIKE AREA W/SAND TO CONTAIN SPILLED LIQUID. OPEN ALL WINDOWS &
DOORS. PUMP INTO SALVAGE TANK.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS COOL, DRY & AWAY FROM
IGNITION SOURCES. CHECK ALL CONTAINERS FOR LEAKS.
Other Precautions:OVERHEATING MAY CAUSE CONTAINER TO RUPTURE & EMPTY
CONTAINERS CONTAINING RESIDUE MAY CAUSE A HAZARD. AVOID BREATHING
FUMES & CONTACT W/SKIN. DON'T TAKE INTERNALLY. WASH THOROUGHLY
AFTER HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE A MSHA/NIOSH APPROVED VAPOR RESPIRATOR.
Ventilation:PROVIDE LOCAL EXHAUST/MECHANICAL VENTILATION TO KEEP <TLV.
IMPERVIOUS CLOTHING & BOOTS.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
PRODUCT DOES NOT CONTAIN LEAD OR CHROMATE PIGMENTS.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:279-313F
Vapor Pres:1.22-2.0
Vapor Density:3.38-3.42
Spec Gravity:0.969-1.464
Evaporation Rate & Reference:SLOWER THAN BU AC
Solubility in Water:<0.1%
Appearance and Odor:CLEAR & COLORED PASTE W/PUNGENT ODOR.
Percent Volatiles by Volume:66-71%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, ALKALIES, & ACIDS.
Stability Condition to Avoid:EXTREME HEAT, COLD, & ELEVATED TEMPS.
Hazardous Decomposition Products:ACRID SMOKE, CO, CO2, & VARIOUS
HYDROCARBONS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS. KEEP MATERIAL OUT OF SEWERS & STREAMS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CARBON DIOXIDE IN NITROGEN
CAGE:3Y341
CAGE:1L753
CAGE:3Y341
CAGE:54262
============= Composition/Information on Ingredients =============
Ingred Name:CARBON DIOXIDE
CAS:124-38-9
RTECS #:FF6400000
Fraction by Wt: 20%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5000 PPM
ACGIH TLV:5000PPM/30000STEL;95
Ingred Name:NITROGEN
CAS:7727-37-9
RTECS #:QW9700000
Fraction by Wt: 80%
Other REC Limits:NONE RECOMMENDED
ACGIH TLV:ASPHYXIANT; 9495
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION OF HIGH
CONCENTRATIONS OF CARBON DIOXIDE AMY CAUSE PARALYSIS OF BREATHING
CONTROL CENTERS OF CNS; COLLAPSE & DEATH MAY OCCUR. MIXTURE ACTS AS
SIMPLE ASPHYXIANT.CHRONIC: NONE SPECIF IED BY MANUFACTURER.
Explanation of Carcinogenicity:NO INGREDIENT OF A CONCENTRATION OF 0.1%
OR GREATER IS LISTED AS A CARCINOGEN OR SUSPECTED CARCINOGEN.
Effects of Overexposure:RAPID RESPIRATION, MUSCUALR INCOORDINATION,
FATIGUE, NAUSEA, VOMITING & UNCONSCIOUSNESS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALED-IMMEDIATELY REMOVE TO FRESH AIR. GIVE ARTIFICIAL
RESPIRATION IF BREATHING STOPPED. GIVE OXYGEN IF BREATHING
DIFFICULT.
===================== Fire Fighting Measures =====================
Extinguishing Media:MEDIA APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE GEAR. COOL FIRE EXPOSED CONTAINERS WITH WATER.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE AND VENTILATE AREA. REMOVE LEAKING
CYLINDE TO EXHAUST HOOD OR OUTDOORS IF THIS CAN BE DONE SAFELY.
SHUT OFF GAS SOURCE IF POSSIBLE AND REMOVE SOURCES OF HEAT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY, WELL-VENTILATED
PLACE. KEEP VALVE PROTECTION CAP IN PLACE WHEN NOT IN USE AND
SECURE CYLINDER WHEN USING TO PROTECT FROM FALLING
Other Precautions:USE SUITABLE HAND TRUCK TO MOVE CYLINDERS. PROTECT
CONTAINERS FROM PHYSICAL DAMAGE. DO NOT DEFACE CYLINDERS OR LABELS.
CYLINDERS SHOULD BE REFILLED BY QUALIFIED PRODUCERS OF COMPRESSED
GASES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF ENGINEERING CONTROLS FAIL OR NON-ROUTINE USE
OR AN EMERGENCY OCCURS; WEAR AN MSHA/NIOSH APPROVED AIR-SUPPLIED
RESPIRATOR OR SCBA, AS REQUIRED. USE IN ACCORDANCE WITH 29 CFR
1910.134 AND MANUFACTURE R'S RECOMMENDATIONS.
Ventilation:USE ADEQUATE MECHANICAL VENTILATION OR LOCAL EXHAUST TO
MAINTAIN EXPOSURE BELOW TLV(S).
Other Protective Equipment:SAFETY SHOES.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING AND BEFORE
EATING, DRINKING OR SMOKING. LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
SHIPMENT OF A COMPRESSED GAS CYLINDER WHICH AHS NOT BEEN FILLED BY THE
OWNER OR WITHIN HIS WRITTEN CONCENT IS A VIOLATION OF FEDERAL LAW
(49 CFR). PER DLSC-TIR: CYLINDERS ARE NONFILLABLE (FOR THIS NSN ).
================== Physical/Chemical Properties ==================
HCC:G3
Decomp Temp:Decomp Text:>3092F,>170
Vapor Density:0.970
Solubility in Water:SLIGHT
Appearance and Odor:COLORLESS, ODORLESS GAS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACRYLALDEHYDE, ETHYLENEIMINE, ALKALINE MATERIALS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:DECMPOSES WHEN HEATED ABOVE 1700C TO
OXYGEN AND CARBON MONOXIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:RETURN CYLINDERS TO SUPPLIER FOR PROPER DISPOSAL
WITH ANY VALVE OUTLET PLUGS OR CAPS SECURED AND VALVE PROTECTION
CAP INPLACE. ALLOW GAS TO VENT SLOWLY TO ATMOSPHERE IN AN
UNCONFINED AREA OR EXHAUST H OOD.
| 0 | gloves_not_mandatory |
Subsets and Splits
No community queries yet
The top public SQL queries from the community will appear here once available.