text
stringlengths 542
18.7k
| label
int64 0
1
| label_text
stringclasses 2
values |
|---|---|---|
===================== Product Identification =====================
Product ID:ORANGE GLO
CAGE:APPEL
CAGE:APPEL
============= Composition/Information on Ingredients =============
Ingred Name:MINERAL SPIRITS
Fraction by Wt: 60-70%
Ingred Name:ORANGE OIL
Fraction by Wt: 10%
Ingred Name:MINERAL OILS
Fraction by Wt: 3%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: MAY CAUSE DIZZINESS,
DROWSINESS, HEADACHE, NAUSEA & VOMITING. EYES: MAY CAUSE
IRRITATION. SKIN: PROLONGED/REPEATED CONTACT MAY CAUSE IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: MAY CAUSE DIZZINESS, DROWSINESS,
HEADACHE, NAUSEA & VOMITING. EYES: MAY CAUSE IRRITATION. SKIN:
PROLONGED/REPEATED CONTACT MAY CAUSE IRRITATION.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/PLENTY OF WATER. SKIN: WASH OFF W/WATER.
INHALATION: REMOVE TO FRESH AIR. GIVE OXYGEN/CPR IF NECESSARY.
INGESTION: DON'T INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:241F
Lower Limits:1
Upper Limits:6
Extinguishing Media:DRY CHEMICAL, CO2, FOAM, CLASS BC, ABC FIRE
EXTINGUISHER
Fire Fighting Procedures:USE SCBA & PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATION AREA. CONTAIN ALL SPILLS & LEAKS
TO PREVENT DISCHARGE INTO THE ENVIRONMENT. SMALL: SOAK UP
W/ABSORBANT, SHOVEL INTO WASTE CONTAINER & FLUSH AREA W/WATER.
LARGE: RECOVER LIQUID FOR REPROCES SING/DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID OVERHEATING
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR FOR ORGANIC
VAPORS, AIR-LINE RESPIRATOR/SCBA.
Ventilation:REQUIRED
Other Protective Equipment:IMPERVIOUS CLOTHING, EYEWAH STATION & SAFETY
SHOWER.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:285F
Vapor Pres:40
Vapor Density:>1
Evaporation Rate & Reference:SLOWER THAN ETHYL ETHER
Percent Volatiles by Volume:>90/WT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:OVERHEATING
Hazardous Decomposition Products:CO, SILICONE DIOXIDE SMOKE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/LOCAL, STATE & FEDERAL
REGULATIONS. EMPTY CONTAINER MAY RETAIN VAPOR/PRODUCT RESIDUE.
OBSERVE ALL LABELED SAFEGUARDS UNTIL CONTAINER IS CLEANED,
RECONDITIONED/DESTROYED.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:PRIMER COATING, EPOXY, RED, COMP B
Kit Part:Y
Preparer's Name:FRED ARMSTRONG
CAGE:OBRN9
CAGE:33832
CAGE:OBRN9
============= Composition/Information on Ingredients =============
Ingred Name:N-BUTYL ALCOHOL (SARA III)
CAS:71-36-3
RTECS #:EO1400000
Fraction by Wt: 11.6%
OSHA PEL:100 PPM
ACGIH TLV:S, C 50 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:2-ETHOXYETHANOL (EGEE) (SARA III)
CAS:110-80-5
RTECS #:KK8050000
Fraction by Wt: 16.9%
OSHA PEL:S,200 PPM
ACGIH TLV:S, 5 PPM; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 8.3%
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:VOC. ORGANIC CMPD 5.5 LB/GAL LESS WATER & NPRS* 661 G/L
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Health Hazards Acute and Chronic:OVEREXPOSURE-NAUSEA, HEADACHE,
DIZZINESS CAUSED BY OVER INHALATION.
Explanation of Carcinogenicity:NA
Effects of Overexposure:OVEREXPOSURE-NAUSEA, HEADACHE, DIZZINESS CAUSED
BY OVER INHALATION.
Medical Cond Aggravated by Exposure:NONE GENERALLY KNOWN
======================= First Aid Measures =======================
First Aid:EYE: FLUSH WITH WATER 15 MINUTES OR UNTIL IRRITATION
SUBSIDES. IF IRRITATION PERSISTS CALL PHYSICIAN. SKIN: REMOVE
CONTAMINATED CLOTHING & WASH THROUGHLY WITH SOAP & WATER.
INHALATION: IF OVERCOME BYVAPORS, REMOVE TO FRESH AIR, CALL
APHYSICIAN. AND INGESTION: DO NOT INDUCE VOMITING, CALL PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:47 F/ 7 C
Lower Limits:1.2
Upper Limits:15.6
Extinguishing Media:CARBON DIOXIDE, FOAM, WATER FOG OR DRY CHEMICAL
Fire Fighting Procedures:USE AIR SUPPLIED BREATHING EQUIPMENT FOR
ENCLOSED CONTAINERS WITH WATER SPRAY. AVOID BREATHING VAPOR OR
FUMES.
Unusual Fire/Explosion Hazard:IF LEAK OR SPILL HAS IGNITED, USE WATER
SPRAY TO DISPERSE THE VAPORS FROM FIRE FIGHTERS.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL IGNITION SOURCES. KEEP FROM HEAT,
SPARK& OPEN FLAME. ADD ABSORBENT (SAND, EARTH, SAWDUST)TO SPILL.
VENTILATE AREA. IF LARGE: KEEP PRODUCT FROM ENTERING SEWERS &
WATERCOURSES BY DIKING. AD- VISE AUTHORITIES IF PRODUCT DOES ENTER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM IGNITION SOURCES. KEEP
IN COOL DRYWELL VENTILATED AREAS. AVOID DIRECT SUNLIGHT & EX-TREME
TEMPERATURES, HOT OR COLD.
Other Precautions:AVOID EYE, SKIN CONTACT, INHALATION, INGESTION OF
MISTS, SPRAY OR VAPORS. AVOID BREATHING SANDING OR BLASTING DUST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE HYDROCARBON VAPOR CANISTER OR SUPPLIED AIR
RESPIRATOR IN CONFINED AREA.
Ventilation:LOCAL EXHAUST-FACE VELOCITY 60FPM, SPECIAL-USE ONLY WITH
ADEQUATE VENTILATION, MECHANICAL-USE EXPLOSION PROOF EQUIPMENT
Other Protective Equipment:USE CHEMICAL RESISTANT APRON OR CLOTHING.
Supplemental Safety and Health
FLAMMABLE LIQUID
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:230 F/110 C
Melt/Freeze Pt:M.P/F.P Text:0 F/-17.8 C
Decomp Temp:Decomp Text:600 F/316 C
Vapor Pres:38 @ 68 F
Vapor Density:3.0 @ 77 F
Spec Gravity:0.924
pH:NA
Viscosity:12-20 4FC
Evaporation Rate & Reference:1.5 (BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:TRANSPARENT LIQUID WITH ALCOHOL ODOR
Percent Volatiles by Volume:37
Corrosion Rate:NA
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CAN REACT WITH OXIDIZING MATERIAL WHEN HEATED TO DECOMPOSI- TION
Stability Condition to Avoid:HIGH TEMPERATURES
Hazardous Decomposition Products:CARBON MONOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:ASSURE CONFORMITY WITH APPLICABLE DISPOSAL
REGULA-TIONS DISPOSE OF ABSORBED MATERIAL AT AN APPROVED DISPOSAL
SITE OR FACILITY. DISPOSE IN CONFORMITY WITH STATE & FEDERAL
REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:150 HYDRAULIC OIL, CM40885
CAGE:9V710
Contract Num:SP0 400-99-AB989 0662
CAGE:61125
CAGE:9V710
============= Composition/Information on Ingredients =============
Ingred Name:DISTILLATE SOLVENT DEWAXED OILS
CAS:64742-65-0
Code:F
RTECS #:PY8038500
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
Ingred Name:2-PROPENOIC ACID, 2-METHYL-DECYL ESTER, POLYMER WITH
DODECYL 2-METHYL-2-PROPENATE
CAS:104199-42-0
Other REC Limits:NONE RECOMMENDED
Ingred Name:DIPHENYLAMINE
CAS:122-39-4
RTECS #:JJ7800000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 MG/M3
ACGIH TLV:10 MG/M3
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS: EYE, SKIN, RESPIRATORY
AND GI TRACTS (HMIS). ACUTE - EYE CONTACT: EYE IRRITANT, BASED ON
DATA FROM COMPONENTS OR SIMILAR MATERIAL. SKIN CONTACT: SKIN
IRRITANT, BASED ON DATA FROM COMPON ENTS OR SIMILAR MATERIAL.
PROLONGED OR REPEATED CONTACT AS FROM CLOTHING WET WITH MATERIAL
MAY CAUSE DERMATITIS. INHALATION: VAPORS (GENERATED AT HIGH
TEMPERATURES ONLY) OR OIL MISTS MAY BE IRRITATIN G TO MUCOUS
MEMBRANES AND THE UPPER RESPIRATORY TRACT BASED ON DATA FROM
COMPONENTS OR SIMILAR MATERIAL. INGESTION: LOW ORDER OF ACUTE ORAL
TOXICITY. MAY CAUSE IRRITATION, VOMITING. ASPIRATION INTO LU NG MAY
CAUSE DEATH. CHRONIC - UNKNOWN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, NAUSEA, VOMITING, TEARING, BLURRED
VISION, DRY SKIN, EDEMA, DEFATING, CRACKING OF SKIN, DERMATITIS,
DEATH
======================= First Aid Measures =======================
First Aid:GET MEDICAL HELP IF SYMPTOMS DEVELOP OR PERSIST. INHALATION:
REMOVE EXPOSED PERSON TO FRESH AIR IF ADVERSE EFFECTS ARE OBSERVED.
EYE CONTACT: FLUSH WITH WATER FOR AT LEAST15 MINUTES. HOLD EYELIDS
OPEN . SKIN: WASH WITH SOAP AND WATER. LAUNDER CONTAMINATED
CLOTHING BEFORE REUSE. INGESTION: DO NOT INDUCE VOMITING. IF
PATIENT IS FULLY CONSCIOUS, DRINK 2 GLASSES OF WATER. SEEK MEDICAL
ATTENTION IMMEDIA TELY.
===================== Fire Fighting Measures =====================
Flash Point:=187.8C, 370.F
Lower Limits:1%
Upper Limits:10%
Extinguishing Media:C02, DRY CHEMICAL, FOAM, WATER SPRAY, WATER FOG
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS WITH
FULL FACE PIECE. COOL EXPOSED CONTAINERS WITH WATER SPRAY. AVOID
BREATHING FUMES.
Unusual Fire/Explosion Hazard:TOXIC FUMES MAY BE EVOLVED ON BURNING OR
EXPOSURE TO HEAT. PRESSURE MAY INCREASE IN OVERHEATED CLOSED
CONTAINERS. STORE BELOW 120F.
================== Accidental Release Measures ==================
Spill Release Procedures:PREVENT ENTERY INTO SEWERS AND WATERWAYS. PICK
UP FREE LIQUID FOR RECYCLE OR DISPOSAL. ABSORB SMALL AMOUNTS WITH
AN INERT ABORBENT SUCH AS SAND, CLAY, EARTH. TRANSFER TO PROPER
CONTAINERS FOR DISPOSAL . REPORT SPILLS AS REQUIRED TO AUTHORITIES.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT HANDLE OR STORE NEAR HEAT OR
FLAMES. KEEP CONTAINER CLOSED WHEN NOT IN USE.
Other Precautions:AVOID BREATHING OIL MISTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NORMALLY NOT REQUIRED, MASK OR RESPIRATORY FOR
MISTS.
Ventilation:USE LOCAL EXHAUST VENTILATION TO CONTROL DUST.
Other Protective Equipment:AS NEEDED TO PREVENT REPEATED OR PROLONGED
CONTACT.
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. WASH AFTER HANDLING AND BEFORE EATING,
DRINKING OR SMOKING.
Supplemental Safety and Health
PART NUMBER: HF-100.
================== Physical/Chemical Properties ==================
HCC:V6
Vapor Pres:<0.01MMHG@20C
Vapor Density:>1 AIR=1
Spec Gravity:0.87
pH:ESSEN. NEUTRAL
VOC Grams/Liter:7.27
Viscosity:30-34CST@40C
Evaporation Rate & Reference:<0.01@1 ATM NBUACETATE=1
Solubility in Water:INSOLUBLE
Appearance and Odor:AMBER VISCOUS LIQUID WITH MILD PETROLEUM OIL LIKE
ODOR
Percent Volatiles by Volume:NEG@38C 4HR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS AND ACIDS
Hazardous Decomposition Products:SMOKE, CARBON MONOXIDE, ALDEHYDES AND
OTHER PRODUCTS OF INCOMPLETE COMBUSTION. HYDROGEN SULFIDE, SHORT
CHAIN ALKYL MERCAPTANS AND OXIDES OF PHOSPHORUS, SULFUR AND ZINC
MAY BE FORMED.
===================== Ecological Information =====================
Ecological:NONE KNOWN
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF WASTE IN ACCORDANCE WITH LOCAL,
STATE, AND FEDERAL LAWS AND REGULATIONS. MATERIALS MAY BECOME
HAZARDOUS WASTE THROUGH USE. IF PERMITTED, INCINERATION MAY BE
PRACTICAL. CONSIDER RECYCLING.
=================== MSDS Transport Information ===================
Transport Information:NOT REGULATED
===================== Regulatory Information =====================
State Regulatory Information:CAL. PROP. 65: NOT DETERMINED
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:DV-9 DEVELOPERS
Preparer's Name:DOYLE W. JACKSON
CAGE:KYOCE
CAGE:25041
CAGE:S7506
CAGE:KYOCE
============= Composition/Information on Ingredients =============
Ingred Name:MANUFACTURER CLAIMS ONLY NON-HAZARDOUS INGREDIENTS W/O
SPECIFYING ANY INDIVIDUAL INGREDIENT.
Fraction by Wt: 100%
Other REC Limits:NONE RECOMMENDED
Ingred Name:ZINC OXIDE
CAS:1314-13-2
RTECS #:ZH4810000
OSHA PEL:15MG/M3 TDUST/5 FUME
ACGIH TLV:10MG/M3 TDUST; 9293
Ingred Name:COPPER OXIDE
CAS:1317-39-1
RTECS #:GL8050000
OSHA PEL:0.1 MG/M3 AS (CU)
ACGIH TLV:0.1 MG/M3 AS (CU)
Ingred Name:SILICA,
CAS:68611-44-9
RTECS #:VV8850000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:6 MG/M3
ACGIH TLV:10 MG/M3 TDUST; 9192
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3; 9192
Ingred Name:POLYPROPYLENE
CAS:9003-07-4
RTECS #:UD1842000
Other REC Limits:NONE RECOMMENDED
Ingred Name:POLYESTER RESIN
CAS:99546-37-9
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:MFR GAVE NO INFORMATION OF MSDS.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MFR GAVE NO INFORMATION OF MSDS.
Explanation of Carcinogenicity:MANUFACTURER GAVE NO INFORMATION ABOUT
CARCINOGENICITY. HMIS FOUND NO LISTING & DOES NOT EXPECT IT TO BE
CARCINOGENIC.
Effects of Overexposure:MFR GAVE NO INFORMATION OF MSDS.
Medical Cond Aggravated by Exposure:MFR GAVE NO INFORMATION OF MSDS.
======================= First Aid Measures =======================
First Aid:MFR GAVE NO INFORMATION OF MSDS.
===================== Fire Fighting Measures =====================
Extinguishing Media:MFR GAVE NO INFORMATION OF MSDS.
Fire Fighting Procedures:MFR GAVE NO INFORMATION OF MSDS.
Unusual Fire/Explosion Hazard:MFR GAVE NO INFORMATION OF MSDS.
================== Accidental Release Measures ==================
Spill Release Procedures:MFR GAVE NO INFORMATION OF MSDS.
Neutralizing Agent:MFR GAVE NO INFORMATION OF MSDS.
======================Handling and Storage ======================
Handling and Storage Precautions:MFR GAVE NO INFORMATION OF MSDS.
Other Precautions:MFR GAVE NO INFORMATION OF MSDS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:MFR GAVE NO INFORMATION OF MSDS.
Ventilation:MFR GAVE NO INFORMATION OF MSDS.
Other Protective Equipment:MFR GAVE NO INFORMATION OF MSDS.
Work Hygienic Practices:MFR GAVE NO INFORMATION OF MSDS.
Supplemental Safety and Health
DV-9 DEVELOPERS MANUFACTURED BY KYOCERA CORP ARE CONSTRUCTED OF PLASTIC
& METAL. THERE ARE NO HAZARDOUS COMPONENTS USED IN THE DEVELOPER.
THEREFORE, MATERIAL SAFETY DATA SHEETS ARE NOT AVAILABLE.
================== Physical/Chemical Properties ==================
HCC:N1
NRC/State Lic Num:NONE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MFR GAVE NO INFORMATION OF MSDS.
Stability Condition to Avoid:MFR GAVE NO INFORMATION OF MSDS.
Hazardous Decomposition Products:MFR GAVE NO INFORMATION OF MSDS.
Conditions to Avoid Polymerization:MFR GAVE NO INFORMATION OF MSDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:MFR GAVE NO INFORMATION OF MSDS.
| 0 |
gloves_not_mandatory
|
===================== Product Identification =====================
Product ID:817 5432, PT A, KODAK 3000 FIXER AND REPLENISHER
Preparer's Name:NOT PROVIDED
CAGE:19139
CAGE:19139
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Minumum % Wt:40.
Maxumum % Wt:45.
Other REC Limits:NOT PROVIDED
Code:F
Code:F
Ingred Name:AMMONIUM THIOSULFATE
CAS:7783-18-8
RTECS #:XN6465000
= Wt:42.
Other REC Limits:NOT PROVIDED
OSHA PEL:NOT PROVIDED
ACGIH TLV:NOT PROVIDED
Ingred Name:SODIUM ACETATE
CAS:127-09-3
RTECS #:AJ4300010
Minumum % Wt:5.
Maxumum % Wt:10.
Other REC Limits:NOT PROVIDED
OSHA PEL:NOT PROVIDED
ACGIH TLV:NOT PROVIDED
Ingred Name:BORIC ACID
CAS:10043-35-3
RTECS #:ED4550000
Minumum % Wt:1.
Maxumum % Wt:5.
Other REC Limits:NOT PROVIDED
OSHA PEL:NOT PROVIDED
ACGIH TLV:NOT PROVIDED
Ingred Name:AMMONIUM SULFITE
CAS:10196-04-0
Minumum % Wt:1.
Maxumum % Wt:5.
Other REC Limits:NOT PROVIDED
OSHA PEL:NOT PROVIDED
ACGIH TLV:NOT PROVIDED
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ACETIC ACID
CAS:64-19-7
RTECS #:AF1225000
Minumum % Wt:1.
Maxumum % Wt:5.
Other REC Limits:NOT PROVIDED
OSHA PEL:10 PPM
ACGIH TLV:10 PPM
ACGIH STEL:15 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:SODIUM BISULFITE
CAS:7631-90-5
RTECS #:VZ2000000
< Wt:1.
Other REC Limits:NOT PROVIDED
OSHA PEL:NOT PROVIDED
ACGIH TLV:5 MG/M3
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT) > 2540 MG/KG
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: EXPECTED TO BE A LOW
HAZARD FOR RECOMMENDED HANDLING. IN CONTACT WITH STRONG ACIDS OR IF
HEATED, SULFITES MAY LIBERATE SULFUR DIOXIDE GAS. SULFUR DIOXIDE
GAS IS IRRITATING TO THE RESPIRATO RY TRACT. SOME ASTHMATICS OR
HYPERSENSITIVE INDIVIDUALS MAY EXPERIENCE DIFFICULT BREATHING.
EYES: NO SPECIFIC HAZARD KNOWN. MAY CAUSE TRANSIENT IRRITATION.
SKIN: MAY BE ABSORBED IN TOXIC AMOUNTS THROU GH DAMAGED OR ABRADED
SKIN. THIS MATERIAL HAS A LOW POTENTIAL TO CAUSE ALLERGIC SKIN
REACTIONS; HOWEVER, CASES OF HUMAN SKIN SENSITIZATION HAVE BEEN
REPORTED. INGESTION: MAY BE HARMFUL IF SWALLOWED.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: IN CONTACT WITH STRONG ACIDS OR IF
HEATED, SULFITES MAY LIBERATE SULFUR DIOXIDE GAS. SULFUR DIOXIDE
GAS IS IRRITATING TO THE RESPIRATORY TRACT. SOME ASTHMATICS OR
HYPERSENSITIVE INDIVIDUAL S MAY EXPERIENCE DIFFICULT BREATHING.
EYES: MAY CAUSE TRANSIENT IRRITATION.
Medical Cond Aggravated by Exposure:SOME ASTHMATICS, HYPERSENSITIVE OR
SULFITE-SENSITIVE INDIVIDUALS MAY EXPERIENCE DIFFICULT BREATHING,
WHEEZING, CHEST TIGHTNESS, STOMACH UPSET, HIVES, FAINTNESS,
WEAKNESS AND DIARRHEA.
======================= First Aid Measures =======================
First Aid:INHALATION: IF SYMPTOMATIC, MOVE TO FRESH AIR. TREAT
SYMPTOMATICALLY. GET MEDICAL ATTENTION IF SYMPTOMS OCCUR. EYES: ANY
MATERIAL THAT CONTACTS THE EYE SHOULD BE WASHED OUT IMMEDIATELY
WITH WATER. GET MEDICAL ATTENTION IF SYMPTOMS OCCUR. SKIN: WASH
WITH SOAP AND WATER. GET MEDICAL ATTENTION IF SYMPTOMS OCCUR.
INGESTION: ONLY INDUCE VOMITING AT THE INSTRUCTION OF MEDICAL
PERSONNEL. CALL A PHYSICIAN OR POISON CONTROL CENTER IMMEDIATELY.
NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:FLOOD WITH WATER.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING. FIRE OR EXCESSIVE HEAT MAY PRODUCE HAZARDOUS
DECOMPOSITION PRODUCTS.
Unusual Fire/Explosion Hazard:SOLUTION CONTAINS A STRONG REDUCING
AGENT. DRIED PRODUCT RESIDUE CAN ACT AS A REDUCING AGENT.
================== Accidental Release Measures ==================
Spill Release Procedures:COLLECT IN A NONCOMBUSTIBLE CONTAINER FOR
PROMPT DISPOSAL.
Neutralizing Agent:NOT PROVIDED
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED TO
PREVENT LOSS OF WATER. DO NOT STORE OR SHIP TOGETHER WITH
COMBUSTIBLE MATERIAL. STORE IN ORIGINAL CONTAINER. KEEP FROM
CONTACT WITH OXIDIZING MATERIALS, HIGHLY OXYGENA TED OR HALOGENATED
SOLVENTS, ORGANIC COMPOUNDS CONTAINING REDUCIBLE FUNCTIONAL GROUPS.
Other Precautions:AVOID BREATHING MIST AT CONCENTRATIONS GREATER THAN
THE EXPOSURE LIMITS. AVOID CONTACT WITH EYES, SKIN, AND CLOTHING.
USE WITH ADEQUATE VENTILATION. WASH THOROUGHLY AFTER HANDLING. KEEP
AWAY FROM COMB USTIBLE MATERIAL. REMOVE AND WASH CONTAMINATED
CLOTHING PROMPTLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED. A RESPIRATOR SHOULD BE
WORN IF HAZARDOUS DECOMPOSITION PRODUCTS ARE LIKELY TO BE OR HAVE
BEEN RELEASED. RESPIRATOR TYPE: FULL-FACE POSITIVE-PRESSURE
AIR-SUPPLIED. IF RESPIRATOR S ARE USED, A PROGRAM SHOULD BE
INSTITUTED TO ASSURE COMPLIANCE WITH OSHA STANDARD 29 CFR 1910.134.
Ventilation:GOOD GENERAL VENTILATION (TYPICALLY 10 AIR CHANGES PER
HOUR) SHOULD BE USED. VENTILATION RATES SHOULD BE MATCHED TO
CONDITIONS.
APPROPRIATE FOR RISK OF EXPOSURE
Other Protective Equipment:EYE BATH, SAFETY SHOWER, WASHING FACILITIES
Work Hygienic Practices:NOT PROVIDED
Supplemental Safety and Health
SUPPLEMENTARY LOCAL EXHAUST VENTILATION, CLOSED SYSTEMS, OR RESPIRATORY
PROTECTION MAY BE NEEDED IN SPECIAL CIRCUMSTANCES SUCH AS POORLY
VENTILATEDSPACES, EVAPORATION FROM LARGE SURFACES, SPRAYING,
HEATING, ETC.
================== Physical/Chemical Properties ==================
HCC:N1
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:>100.C, 212.F
Melt/Freeze Pt:M.P/F.P Text:NOT PROVIDED
Decomp Temp:Decomp Text:NOT PROVIDED
Vapor Pres:68F: 24 MBAR (18 MM HG)
Vapor Density:0.6
Spec Gravity:1.32
pH:5.0
Viscosity:NOT PROVIDED
Evaporation Rate & Reference:NOT PROVIDED
Solubility in Water:COMPLETE.
Appearance and Odor:LIQUID, LIGHT YELLOW, SLIGHT SULFUR & ACETIC ACID
ODOR.
Percent Volatiles by Volume:40-45 WT
Corrosion Rate:NOT PROVIDED
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
BASES, SODIUM HYPOCHLORITE (BLEACH), STRONG OXIDIZING AGENTS,
COMBUSTIBLE MATERIAL, HALOGENATED MATERIALS, STRONG ACIDS. CONTACT
WITH BASE LIBERATES FLAMMABLE MATERIAL.
Stability Condition to Avoid:NOT PROVIDED
Hazardous Decomposition Products:AMMONIA, SULFUR DIOXIDE, CHLORAMINE.
CARBON MONOXIDE, CARBON DIOXIDE, OXIDES OF NITROGEN;
=================== Toxicological Information===================
Toxicological Information:EFFECTS OF EXPOSURE: CONTAINS: BORIC ACID.
BASED ON REPEATED-DOSE INGESTION STUDIES IN ANIMALS, MAY CAUSE
ADVERSE REPRODUCTIVE AND DEVELOPMENTAL EFFECTS. HOWEVER, THE DOSES
ADMINISTERED WERE MANY TIME S THOSE TO WHICH HUMANS WOULD NORMALLY
BE EXPOSED. ACUTE TOXICITY DATA: ORAL LD-50 (RAT): > 2540 MG/KG
DERMAL LD-50: > 20 ML/KG SKIN IRRITATION: SLIGHTEYE
IRRITATION: SLIGHT
===================== Ecological Information =====================
Ecological:THE FOLLOWING PROPERTIES ARE ESTIMATED FROM THE COMPONENTS
OF THE PREPARATIONS. POTENTIAL TOXICITY: FISH LC50 MG/L: >100.
DAPHNID EC50 MG/L: >100.ALGAL IC50 MG/L: >100. ORGANICS
READILY DEGRAD ABLE (>70%): YES (7 DAYS). POTENTIAL
BIOACCUMULATION: LOG POW <1. COD (APPROXIMATE G/L): 347. BOD5
(APPROXIMATE G/L): 280. POTENTIAL TOXICITY: WASTE TREATMENT
MICROORGANISMS EC50 (MG/L): >100.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT, OR DISPOSAL MAY BE SUBJECT
TO NATIONAL, STATE, OR LOCAL LAWS. FLUSH TO SEWER WITH LARGE AMOUNT
OF WATER. SINCE EMPTIED CONTAINERS RETAIN PRODUCT RESIDUE, FOLLOW
LABEL WARNINGS EV EN AFTER CONTAINER IS EMPTIED.
=================== MSDS Transport Information ===================
Transport Information:FOR TRANSPORTATION INFORMATION REGARDING THIS
PRODUCT CALL THE KODAK WORLDWIDE TRANSPORTATION HAZMAT HOT LINE:
(716) 722-2400 BETWEEN 8 A.M. AND 5 P.M. (EASTERN STANDARD TIME),
MONDAY THROUGH FRIDAY .
===================== Regulatory Information =====================
SARA Title III Information:CHEMICAL(S) SUBJECT TO THE REPORTING
REQUIREMENTS OF SECTION 313 OR TITLE III OF THE SUPERFUND
AMENDMENTS AND REAUTHORIZATION ACT (SARA) OF 1986 AND 40 CFR PART
372: AMMONIUM THIOSULFATE, AS A SOURC E OF AQUEOUS AMMONIA.
Federal Regulatory Information:NOT PROVIDED
State Regulatory Information:MATERIAL(S) KNOWN TO THE STATE OF
CALIFORNIA TO CAUSE CANCER: NONE MATERIAL(S) KNOWN TO THE STATE OF
CALIFORNIA TO CAUSE ADVERSE REPRODUCTIVE EFFECTS: NONE
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:GLUTARIC DIALDEHYDE, 50 WT %SOLUTION IN WATER,34085-5
CAGE:60928
CAGE:60928
============= Composition/Information on Ingredients =============
Ingred Name:GLUTARALDEHYDE
CAS:111-30-8
RTECS #:MA2450000
OSHA PEL:0.2 PPM,C
ACGIH TLV:0.2 PPM,C
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(ORAL,RAT)134 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: HARMFUL IF SWALLOWED, INHALED,
OR ABSORBED THRU SKIN. MATL IS EXTREMELY DESTRUCTIVE TO TISSUE OF
MUC MEMB & UPPER RESP TRACT, EYES & SKIN. INHAL MAY BE FATAL AS A
RSLT OF SPASM, INFLAMM & EDEMA OF LARYNX & BRONCH, CHEM PNEUM &
PULM EDEMA. SYMPS OF EXPOS MAY INCL BURNING SENSATION, COUGH, (EFTS
OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: WHEEZING, LARYNGITIS, SHORTNESS OF
BRTH, HCH, NAUS & VOMIT. MAY CAUSE ALLERGIC RESP & SKIN RXN. TO THE
BEST OF MFR KNOWLEDGE, THE CHEMICAL, PHYSICAL AND TOXICOLOGICAL
PROPERTIES HAVE NOT BEE N THORO INVESTIGATED.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: IMMED FLUSH WITH COPIOUS AMOUNTS OF WATER FOR AT LEAST
15 MINUTES. ASSURE ADEQ FLUSHING OF EYES BY SEPARATING LIDS
W/FINGERS. SKIN: IMMED FLUSH WITH COPOUS AMOUNTS OF WATER FOR @ LST
15 MIN WHIL E REMOVING CONTAMD CLTHG & SHOES. WASH CONTAMD CLTHG
BEFORE REUSE. INHAL: REMOVE TO FRESH AIR. IF NOT BRTHG GIVE ARTF
RESP.IF BRTHG IS DFCLT, GIVE OXYGEN. CALL A PHYS. INGEST: CALL MD
IMMED .
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WATER SPRAY. CARBON DIOXIDE, DRY CHEMICAL POWDER,
ALCOHOL OR POLYMER FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:EMITS TOXIC FUMES UNDER FIRE CONDITIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR NIOSH/MSHA APPRVD SCBA, RUBBER BOOTS &
CLSD CONTR & HOLD FOR WASTE DISP. VENT AREA & WASH SPILL SITE AFTER
MATL PICKUP IS COMPLE TE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT BREATHE VAP. DO NOT GET IN
EYES, ON SKIN/CLTHG. READILY ABSORBED THRU SKIN.TOX. CORR.
SENSITIZER. KEEP TIGHTLY CLSD. STORE UNDER NITROGEN.
Other Precautions:STORE IN A COOL DRY PLACE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:USE ONLY IN A CHEMICAL FUME HOOD.
Other Protective Equipment:SAFETY SHOWER AND EYE BATH.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Vapor Pres:15@20C
Vapor Density:3.5
Spec Gravity:1.106
Appearance and Odor:COLORLESS LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS. MAY DISCOLOR ON EXPOSURE TO AIR.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:TOXIC FUMES OF: CARBON MONOXIDE,
CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISSOLVE/MIX MATERIAL WITH A COMBUSTIBLE SOLVENT
AND BURN IN A CHEMICAL INCINERATOR EQUIPPED WITH AN AFTERBURNER AND
SCRUBBER. OBSERVE ALL FEDERAL, STATE AND LOCAL LAWS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:SYN-STAR D.E. 32, 02077
CAGE:OTTJ3
CAGE:OTTJ3
CAGE:3B431
============= Composition/Information on Ingredients =============
Ingred Name:SYNTHETIC LUBRICANT CONTAINING PHTHALATE AND ADIPATE
DIESTERS PEL/TLV AS OIL MIST.
Fraction by Wt: 100%
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3;10 STEL
Ingred Name:SUPP DATA: ONCE A WEEK. DRY CLEANING OF CONTAM CLTHG MAY BE
MORE EFT THAN NORMAL LAUNDERING. INFORM INDIV (ING 3)
RTECS #:9999999ZZ
Ingred Name:ING 2: RESPONSIBLE FOR CLEANING OF POTENTIAL HAZARDS
ASSOCIATED WITH HANDLING CONTAMINATED CLOTHING.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC: CONTAINER CLOSED AND DRUM BUNGS IN PLACE.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50: (ORAL,RAT) >10 G/KG.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: MAY CAUSE MINIMAL IRRIT,
EXPERIENCED AS TEMPORARY DISCOMFORT. SKIN: BRIEF CONTACT IS NOT
IRRITATING. PRLNGD CONT, AS WITH CLOTHING WETTED WITH MATERIAL, MAY
CAUSE DEFAT OF SKIN/IRRIT, SEEN AS LOC AL REDNESS WITH POSSIBLE
MILD DISCOMFORT. INHALATION: VAPORS OR MIST, IN EXCESS OF
PERMISSIBLE CONC, (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: OR IN UNUSUALLY HIGH CONC GENERATED
FROM SPRAYING, HEATING MATERIAL OR AS FROM EXPOS IN POORLY VENT
AREAS/CONFINED SPACES, MAY CAUSE IRRIT OF NOSE & THROAT, HEADACHE,
NAUSEA, & DROW. INGEST: IF MORE THAN SEV MOUTHFULS ARE SWALLOWED,
ABDOMINAL DISCOMFORT, NAUSEA, AND DIARR MAY OCCUR.
Medical Cond Aggravated by Exposure:BECAUSE OF ITS DEFATTING
PROPERTIES, PROLONGED AND REPEATED SKIN CONTACT MAY AGGRAVATE AN
EXISTING DERMATITIS (SKIN CONDITION).
======================= First Aid Measures =======================
First Aid:EYE: FLUSH W/PLENTY OF H*2O FOR AT LEAST 15 MIN. GET MED ATTN
IF EYE IRRIT PERSISTS. SKIN: WASH W/PLENTY OF SOAP & H*2O FOR SEV
MIN. GET MED ATTN IF SKIN IRRIT DEVELOPS/PERSISTS. INGEST: IF MORE
THAN SEV MOUTHFULS HAVE BEEN SWALLOWED, GIVE2 GLASSES OF H*2O (16
OZ.). GET MED ATTN. INHAL: IF IRRIT, HDCH, NAUS/DROW OCCURS, REMOVE
TO FRESH AIR. GET MED ATTN IF BRTHG BECOMES DFCLT/SYMP (SUPP DATA)
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:450F,232C
Extinguishing Media:WATER SPRAY, DRY CHEMICAL, FOAM, OR CARBON DIOXIDE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP.
H*2O/FOAM MAY CAUSE FROTHING. USE H*2O TO COOL FIRE-EXPOS CNTNRS.
IF LEAK/SPILL HAS NOT IGNITED,(SUPP DATA)
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:VENT AREA. AVOID BRTHG VAP. USE NIOSH/MSHA
APPRVD SCBA/SUPP AIR FOR LRG SPILLS/CONFINED AREAS. CONT SPILL IF
POSS. WIPE UP/ABSORB ON SUITABLE MATL & SHOVEL UP. PVNT ENTRY INTO
SEWERS AND WATERWAYS. AV OID CONTACT WITH SKIN, EYES OR CLOTHING.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:MIN FEASIBLE HNDLG TEMP SHD BE
MAINTAINED. PERIODS OF EXPOS TO HIGH TEMPS SHD BE MIN. WATER
CONTAMINATION SHOULD BE AVOIDED.
Other Precautions:MISUSE OF EMPTY CNTNRS CAN BE HAZ. EMPTY CNTNRS CAN
BE HAZ IF USED TO STORE TOXIC, FLAM/REACTIVE MATLS. CUTTING/WELDING
OF EMPTY CNTNRS MIGHT CAUSE FIRE, EXPLO/TOX FUMES FROM RESIDUES. DO
NOT PRESSURI ZE/EXPOS TO HEAT/OPEN FLAME. KEEP(ING 4)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AIRBORNE CONC SHD BE KEPT TO LOWEST LEVS POSS.
IF VAP, MIST/DUST IS GEN, USE NIOSH/MSHA APPRVD RESP AS APPROP. USE
NIOSH/MSHA APPRVD SUPP AIR RESP FOR CLEANING LRG SPILL/UPON ENTRY
INTO TANKS, VESSELS /OTHER CONFINED SPACES.
Ventilation:ADEQUATE TO MEET COMPONENT OCCUPATIONAL EXPOSURE LIMITS.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WORKERS SHD WASH EXPOS SKIN SEV TIMES DAILY
W/SOAP & H*2O. SOILED WORK CLTHG SHD BE LAUNDERED/DRY-CLEANED AT
(SUPP DATA)
Supplemental Safety and Health
FIRE FIGHT PROC: USE H*2O SPRAY TO DISPERSE VAPS & TO PROVIDE PROT FOR
PERSONS ATTEMPTING TO STOP LEAK. FIRST AID PROC: PERSIST. WASTE
DISP METH: IS BECAUSE PROD USES, TRANSFORMATIONS, MIXTURES, PROCE
SSES, ETC. MAY RENDER RSLTG MATLS HAZ. DISP MUST BE I/A/W FED,
STATE & LOC REGS . WORK HYGIENE PRACT: LEAST(ING 2)
================== Physical/Chemical Properties ==================
HCC:V6
Boiling Pt:B.P. Text:538F,281C
Vapor Pres:<5.0
Vapor Density:>1.0
Spec Gravity:0.926 (H*2O=1)
Solubility in Water:SLIGHT
Appearance and Odor:CLEAR LIQUID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:HEAT OR COMBUSTION: TOXIC LEVELS OF
CARBON MONOXIDE, CARBON DIOXIDE, IRRITATING ALDEHYDES AND KETONES.
==================== Disposal Considerations ====================
Waste Disposal Methods:PROD HAS BEEN EVALUATED FOR RCRA CHARACT & DOES
NOT MEET CRITERIA OF HAZ WASTE IF DISCARDED IN PURCHASED FORM.
UNDER RCRA, IT IS RESPONSIBILITY OF USER OF PROD TO DETERM AT TIME
OF DISP, WHETHER PROD MEETS RCRA CRITERIA FOR HAZ WASTE.THIS (SUPP
DATA)
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:50-5 SAFETY RED, BREAK-THROUGH
Preparer's Name:BATRICE BLACKMON
CAGE:HO921
CAGE:HO921
============= Composition/Information on Ingredients =============
Ingred Name:ETHANOL, 2-BUTOXY-;(BUTYL CELLOSOLVE). VP:O.6 @ 68F.
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: 9%
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM; 9293
Ingred Name:PHTHALIC ACID, DIBUTYL ESTER;(DIBUTYL PHTHALATE) (SARA III)
CAS:84-74-2
RTECS #:TI0875000
Fraction by Wt: 2%
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:SILICA, CRYSTALLINE - QUARTZ; (SILICA (QUARTZ))
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 0.0-.38%
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
Ingred Name:SUPP DATA:W/ADMIN OF ETHYLENE GLYCOL MONOBUTYL ETHER (EGBE)
& ETHYLENE GLYCOL MONOBUTYL ETHER ACETATE (EGBEA). (ING 5)
RTECS #:9999999ZZ
Ingred Name:ING 4:(ETRACTED FROM DHHS (NIOSH) PUBLICATION NO. 90-118) .
RTECS #:9999999ZZ
Ingred Name:FIRST AID:RESPIRATORY SYMPTOMS DEVELOP, CONSULT MD.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHAL:VAP OF MATL MAY IRRIT NOSE,
THROAT, & RESP PASSAGES. HIGHER CONC CAN INDUCE HDCH, DIZZ, NAUS,
DROWSINESS, & SHORTNESS OF BREATH. SKIN:NO IRRIT IS LIKELY TO
DEVELOP FOLLOWING SHORT CNTCT PERIODS W/HUMAN SKIN. PRLNG/RPTD
EXPOS CAN LEADTO REDNESS/SWELLING/NECROSIS. EYE:CAN INDUCE PAIN &
MOD IRRIT (EFTS OF OVEREXP)
Explanation of Carcinogenicity:SILICA (QUARTZ): GROUP 2A (IARC),
ANTICIPATED TO BE A CARCINOGEN (NTP).
Effects of Overexposure:HLTH HAZ: SKIN ABSORP:ADVERSE SYSTEMIC EFTS CAN
DEVELOP FOLLOWING RPTD/PRLNGD CNTCT W/HUMAN SKIN. INHAL OF HIGH
CONC OF VAP CAN INDUCE ANEMIA, LIVER & KIDNEY INJURY & CLOUDING OF
CORNEA. ACUTE:CAN CAU SE UPPER RESP IRRIT. CHRONIC:PRLNGD OVEREXPOS
BY INHAL MAY CAUSE DELAYED LUNG INJURY/DISEASE (SILICOSIS) (SUPP
DATA)
Medical Cond Aggravated by Exposure:PULMONARY AND/OR RESPIRATORY
DISEASES.
======================= First Aid Measures =======================
First Aid:SKIN:REMOVE CONTAM CLTHG & FOOTWEAR. WASH MATL OFF SKIN
W/SOAP & H*2O. IF REDNESS, ITCHING/BURNING SENSATION DEVELOPS, GET
MD ATTEN. WASH CONTAM CLTHG & DECONTAM FOOTWEAR BEFORE REUSE.
EYE:IMMED FLUSH W/WATER FOR AT LEAST 15 MIN & HAVE EYEEXAMINED &
TREATED BY MD PERS. INGEST:GIVE 1 OR 2 GLASSES OF WATER TO DRINK.
INDUCE VOM. REFER VICTIM TO MD. INHAL:REMOVE TO FRESH AIR. IF
COUGH/OTHER (ING 6)
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:210F,99C
Lower Limits:0.5%
Upper Limits:10.6%
Extinguishing Media:ALCOHOL FOAM, CO*2, DRY CHEMICAL, WATER FOG
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NO UNUSUAL FIRE/EXPLOSION HAZARDS ARE
KNOWN FOR THIS PROD. AS TYPICAL OF CLOSED CONTAINERS CONTAINING
LIQUID, THEY MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:DIKE AND CONTAIN SPILL WITH INERT MATERIALS
(SAND, CLAY, EARTH, ETC). TRANSFER THE LIQUID TO CONTAINER FOR
RECOVERY OR DISPOSAL. KEEP SPILL OUT OF SEWERS AND OPEN BODIES OF
WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP FROM FREEZING. KEEP AWAY FROM
HEAT/OPEN FLAME. AVOID BRTHG VAP. AVOID CONTACT W/EYES/SKIN &
CLTHG. USE W/VENT ADEQ TO MAINTAIN VAP (SUPP DATA)
Other Precautions:HAZ INGRED NOTATED IN INGRED SECTIONS AS "SUBJECT TO
SEC. 313" ARE SUBJECT TO RPT REQ UNDER SECTION 313 OF EMER PLANNING
& COMMUNITY RIGHT-TO-KNOW ACT OF 1986 & OF 40 CFR 372.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF TLV OF THE PRODUCT OR ANY COMPONENT IS
EXCEEDED, USE A NIOSH/MSHA APPROVED RESPIRATOR. IF VAPOR EXPOSURE
CAUSES EYE DISCOMFORT, USE A NIOSH/MSHA APPROVED FULL-FACE
RESPIRATOR.
Ventilation:PROVIDE GENERAL AND/OR LOCAL EXHAUST VENTILAITON TO CONTROL
AIRBORNE LEVEL BELOW THE EXPOSURE GUIDELINES.
Other Protective Equipment:TO PREVENT REPEATED OR PROLONGED SKIN
CONTACT, WEAR IMPERVIOUS CLOTHING AND SHOES.
Work Hygienic Practices:REMOVE CONTAMINATED CLOTHING IMMEDIATELY. WASH
SKIN WITH SOAP AND WATER. LAUNDER CLOTHES BEFORE REUSE.
Supplemental Safety and Health
HDLG/STOR PREC:CONC BELOW TLV. CNTNRS MAY BE HAZ WHEN EMPTIED-ALL HAZ
PREC MUST BE OBSERVED. KEEP OUT OF REACH OF CHILDREN. EFTS OF
OVEREXP:TAKE APPROP MEASURES TO AVOID BRTHG DUST. ANIMAL STUDIES
HAV E CLEARLY DEMONSTRATED DOSE-RELATED EFTS ON CNS, HEMATOPOIETIC
TISS/BLOOD/KIDNEYS/LIVER ASSOC (ING 4)
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:SEE ING
Vapor Density:HVR/AIR
Spec Gravity:1.1-1.3(H*2O=1)
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:MISCIBLE
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIAL & HYDROFLUORIC ACID.
Stability Condition to Avoid:EXCESSIVE HEAT
Hazardous Decomposition Products:COMBUSTION PRODUCT:CO*2, CO
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE
AND FEDERAL REQUIREMENTS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:CLEANUP-NATURAL-PUMICE, 1196
Preparer's Name:JEFFEREY ALDER
CAGE:JO046
CAGE:0G6E4
CAGE:JO046
============= Composition/Information on Ingredients =============
Ingred Name:CYCLOHEXENE, 1-METHYL-4-(1-METHYLETHENYL)-, (R);
(D-LIMONENE)
CAS:5989-27-5
RTECS #:GW6360000
Fraction by Wt: 4-14%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: SKIN: POSSIBLE SKIN RASH. EYES:
MILD IRRITATION. INGESTION: UPSET STOMACH. CHRONIC: NONE SPECIFIED
BY MANUFACTURER.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARD.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTF
RESP) . EYE AND SKIN: FLUSH EYES WITH WATER FOR AT LEAST 15
MINUTES. IF IRRITATION PERSISTS, CONSULT A PHYSICIAN. WASH SKIN
THOROUGHL Y. IF IRRITATION PERSISTS, CONSULT A PHYSICIAN.
INGESTION: DO NOT INDUCE VOMITING. DRINK LARGE QUANTITIES OF WATER
OR MILK. CALL A PHYSICIAN IMMEDIATELY.
===================== Fire Fighting Measures =====================
Extinguishing Media:FOAM, CO*2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . WET MATERIAL IS SLIPPERY. AVOID CONTACT WITH MATERIAL.
Unusual Fire/Explosion Hazard:NONE NOTED.
================== Accidental Release Measures ==================
Spill Release Procedures:FLOOR MAY BE SLIPPERY. NO OTHER HAZARDS KNOWN.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP OUT OF THE REACH OF CHILDREN.
AVOID EYE CONTACT. STORE IN A COOL DRY AREA. ALWAYS KEEP COVER ON
WHEN NOT IN USE.
Other Precautions:CONTAINERS, EVEN THOSE THAT HAVE BEEN EMPTIED WILL
RETAIN PRODUCT RESIDUE AND VAPORS. ALWAYS OBEY HAZARD WARNINGS AND
HANDLE EMPTY CONTAINERS AS IF THEY ARE FULL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:NOT APPLICABLE.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:WASH HANDS BEFORE EATING.
Supplemental Safety and Health
PH: 8.5 +/- 0.5
================== Physical/Chemical Properties ==================
Spec Gravity:1.01 (H*20 = 1)
pH:SUPDAT
Solubility in Water:COMPLETE
Appearance and Odor:THICK ORANGE GEL WITH AN ORANGE ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE NOTED.
Hazardous Decomposition Products:NONE KNOWN.
==================== Disposal Considerations ====================
Waste Disposal Methods:MATERIAL SHOULD BE SCOOPED UP AND PLACED IN
ACCEPTABLE WASTE RECEPTABLE. DISPOSE OF ALL WASTE IN ACCORDANCE
WITH FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:AVIATION OIL 22851 1080 LAP III
Preparer's Name:I.R. SWOAP
CAGE:7A348
CAGE:7A348
============= Composition/Information on Ingredients =============
Ingred Name:MINERAL OIL (EXPOSURE REGULATED AS 'OIL MIST')
CAS:8012-95-1
RTECS #:PY8030000
Other REC Limits:5MG/CUM AS OIL MIST
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3/10 STEL;9192
Ingred Name:ADDITIVE PACKAGE CONTAINING SULFUR,NITROGEN
Fraction by Wt: 5-10%
===================== Hazards Identification =====================
LD50 LC50 Mixture:>5G/KG ORAL RAT;>3G/KG DERMAL RABBIT.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:ACUTE:IRRITATION TO EYES,SKIN AND
RESPIRATORY OR G.I.TRACT. CHRONIC:DERMATITIS,SKIN DISORDERS.
Explanation of Carcinogenicity:USE OILS WERE SHOWN TO CAUSE SKIN CANCER
IN LAB ANIMALS (MICE)
Effects of Overexposure:EYES:IRRITATING (MINIMALLY).SKIN:IRRITATING
(MINIMALLY) INHALATION:IRRITATING TO RESPIRATORY TRACT (NOT
EXPECTED OTHER THAN POSSIBLE IRRITATING)
Medical Cond Aggravated by Exposure:SEVERE IRRITATION OR DERMATITIS.
======================= First Aid Measures =======================
First Aid:INHALE:REMOVE TO FRESH AIR, GIVE CPR/O*2 NEED;EYES/SKIN:FLUSH
W LG AMTS H*2O FOR 15 MIN;INGEST:RINSE MOUTH; GET MEDICAL ATTENTION
FOR EYES, BREATHING DIFFICULTY, OR OTHER SYMPTOMS OF OVEREXPOSURE.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:440F/227C (COC)
Extinguishing Media:WATER SPRAY,DRY CHEMICAL,FOAM,CO*2.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA IN AN ENCLOSED
AREA.
Unusual Fire/Explosion Hazard:NONE NOTED;COMBUSTION
PRODUCT:CO,CO*2,ALDEHYDE,KETONES,COMBUSTION PRODUCTS OF N; AND
SULPHUR.
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION;WIPE UP OR
ABSORB ON SUITABLE INERT MATERIAL AND COLLECT FOR PROPER DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY AND WELL VENTILATED
AREA.KEEP AWAY FROM OPEN FLAMES,HEAT AND FLAMMABLE MATERIALS.KEEP
CONTAINER CLOSED WHEN NOT IN USE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NO SPECIAL REQMNTS UNDER ORDINARY
CONDITIONS/ADEQUATE VENT.
Ventilation:MECH(GEN)OR LOCAL EXHAUST THAT PROVIDES ADEQUATE
VENTILATION
Other Protective Equipment:FULL WORK CLOTHING TO PREVENT REPEATED OR
PROLONG CONTACT.
Work Hygienic Practices:AVOID CONTACT WITH EYES AND SKIN;DO NOT BREATHE
VAPORS/MIST;DO NOT EAT,DRINK OR SMOKE IN WORK AREA.WASH AFTER EACH
USE.
Supplemental Safety and Health
MSDS RECEIVED BY DGSC: 23 OCT,1987.
================== Physical/Chemical Properties ==================
Spec Gravity:0.9007
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BRIGHT AND CLEAR,MILD.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:EXTREME HEAT.
Hazardous Decomposition Products:CO,CO*2,ALDEHYDES & KETONES &
COMBUSTION PRODUCTS OF NITROGEN AND SULFUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF COLLECTED MATERIAL IN ACCORDANCE WITH
LOCAL STATE AND FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:RUST-O-LASTIC ANTI-CORROSIVE PRIMER, 073444
CAGE:85519
CAGE:85519
============= Composition/Information on Ingredients =============
Ingred Name:ZINC OXIDE (SARA 313) (CERCLA)
CAS:1314-13-2
RTECS #:ZH4810000
Fraction by Wt: 1-10%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:TALC (POWDER), CONTAINING NO ASBESTOS FIBERS; (TALC)
CAS:14807-96-6
RTECS #:WW2710000
Fraction by Wt: 11-30%
OSHA PEL:20 MPPCF Z-3
ACGIH TLV:2 MG/M3 RDUST
Ingred Name:MINERAL SPIRITS; (PETROLEUM DISTILLATE-LOW ODOR) VP: 10.0 @
25C; LEL: 1.1%
CAS:64475-85-0
RTECS #:PY8240000
Fraction by Wt: 1-10%
OSHA PEL:100 PPM (MFR)
ACGIH TLV:100 PPM (MFR)
Ingred Name:STODDARD SOLVENT; (PETROLEUM DISTILLATE) VP: 2.0 @ 25C;
LEL: 1.1%
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 11-30%
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
Ingred Name:SILICA, CRYSTALLINE - QUARTZ; (CRYSTALLINE SILICA)
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 1-10%
OSHA PEL:SEE TABLE Z-3
ACGIH TLV:0.1 MG/M3 RDUST
Ingred Name:C.I. PIGMENT YELLOW 42
CAS:51274-00-1
Fraction by Wt: 11-30%
OSHA PEL:15 MG/M3 (MFR)
ACGIH TLV:10 MG/M3 (MFR)
Ingred Name:IRON (III) OXIDE; (C.I. PIGMENT RED 101)
CAS:1309-37-1
RTECS #:NO7400000
Fraction by Wt: 1-10%
OSHA PEL:10 MG/M3 (FE)
ACGIH TLV:5 MG(FE)/M3FUME, B2
Ingred Name:BARIUM SULFATE
CAS:7727-43-7
RTECS #:CR0600000
Fraction by Wt: 1-10%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:BARIUM METABORATE; (BARIUM METABORATE MONOHYDRATE)
CAS:13701-59-2
RTECS #:CQ9570000
Fraction by Wt: 1-10%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL: IRRIT OF RESP TRACT.
PRLNG INHAL MAY LEAD TO FATG, DROW, DIZZ &/LT-HEAD, HDCH, LACK OF
COORD, NAUS, VOMIT, CNS DEPRESS, ANESTH EFT/NARCOSIS. SKIN: IRRIT.
PRLNG/RPTD CONT CAN CAUSE DERM, DEFAT. EYES: IRRIT. PRLNG/RPTD
CONT CANCAUSE BLURRED VISION, REDNESS, TEARING, SEV IRRIT. (EFFECTS
OF OVEREXPOSURE)
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-QUARTZ: IARC
MONOGRAPHS, SUPPLEMENT, VOLUME 7, PAGE 341, 1987: GROUP 2A. NTP 7TH
ANNUAL REPORT ON CARCINOGENS, 1994: ANTICIPATED TO BE CARCINOGEN.
ANIMAL: LUNG.
Effects of Overexposure:HLTH HAZ: INGEST: AMTS INGESTED INCIDENTAL TO
CONSUMER & INDUS HNDLG ARE NOT LIKELY TO CAUSE INJURY; HOWEVER,
INGEST OF LARGER AMTS MAY CAUSE LUNG INFLAMM & DMG DUE TO ASPIR OF
MATL INTO LUNGS. CHRONI C: RPTS HAVE ASSOC RPTD & PRLNG OCCUP
OVEREXP TO SOLVS W/PERM BRAIN & NERV SYS DMG. INTENTIONAL MISUSE BY
DELIBERATELY CONCENTRATING & INHALING CONTENTS MAY BE
HARMFUL/FATAL.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. RESTORE & SUPPORT CONTINUED
BREATHING. HAVE TRAINED PERSON GIVE OXYGEN IF NECESSARY. GET EMER
MED ATTN. SKIN: WASH OFF QUICKLY W/PLENTY OF WATER, THEN SOAP &
WATER; REMOVE CONTAM CLTHG & WASH BEFORE REUSE. EYES:FLUSH IMMED
W/LARGE AMOUNTS OF WATER, ESP UNDER LIDS, FOR AT LEAST 15 MIN.
OBTAIN EMER MED TREATMENT. INGEST: OBTAIN MED TREATMENT IMMED.
===================== Fire Fighting Measures =====================
Flash Point:106F,41C
Lower Limits:SEE INGS
Extinguishing Media:DRY CHEMICAL OR FOAM.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . WATER MAY BE USED TO COOL AND PROTECT EXPOSED
CONTAINERS.
Unusual Fire/Explosion Hazard:CLSD CONTRS MAY EXPLODE WHEN EXPOSED TO
EXTREME HEAT/FIRE. VAPS CAN FORM EXPLO MIXTURES IN AIR AT ELEVATED
TEMPS. MAY DECOMPOSE UNDER FIRE CNDTNS EMITTING IRRIT &/TOX GASES.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION (FLAME, HOT
SURFACES, AND ELECTRICAL, STATIC SPARKS). VENTILATE AREA AND AVOID
BREATHING VAPORS. CONTAIN AND REMOVE WITH INERT ABSORBENT MATERIAL
USING NON-SPARKING TOOL S.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE IN SUN/ABOVE 100F. STORE
LGE QTYS IN BLDGS DESIGNED FOR STOR OF FLAMM/COMBUST LIQS. DO NOT
TAKE INTERNALLY.
Other Precautions:DO NOT WELD/FLAME CUT W/OUT PROPER VENT TO INSURE
AREA IS FREE OF FLAMM VAPS. DO NOT CUT, PUNCTURE/WELD ON/NEAR
CONTR. ENTRANCE INTO CLSD STOR TANKS: USE APPROP NIOSH APPRVD
RESP/AIRLINE FOR POSS EXPO S TO SOLV/CHEM FUMES. RAGS OR WASTE
CONTAINING OIL BASE PAINT/VARNISH THAT PRESENT LGE AIR-TO-OIL IN
TERFACE WILL(SUPDAT)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:CONTROL ENVIRONMENTAL CONCENTRATIONS BELOW
APPLICABLE STANDARDS. APPROVED CHEMICAL MECHANICAL FILTER
RESPIRATOR DESIGNED TO REMOVE A COMBINATION OF PARTICULATE AND
VAPORS (NIOSH TC23C OR EQUIVALENT).
Ventilation:ALL APPLICATION AREAS SHOULD BE VENTILATED IN ACCORDANCE
W/OSHA 29 CFR 1910 DURING USE AND UNTIL AREA IS FREE OF VAPORS.
Other Protective Equipment:EMERGENCY EYEWASH AND DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
OTHER PRECAUTIONS: OXIDIZE & MAY IGNITE SPONTANEOUSLY AND SHOULD BE
PLACED IN METAL CONTAINER. KEEP OUT OF THE REACH OF CHILDREN.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>275F,>135C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN ETHYL ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER
Percent Volatiles by Volume:42.40-46.40
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS, ACIDS, BASES, AMINES.
Stability Condition to Avoid:ELEVATED TEMPERATURES. CONTACT WITH
OXIDIZING AGENTS.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. AVOID DISCHARGE TO NATURAL WATERS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:DELO 400 SAE 20, CPS238051
CAGE:8X116
CAGE:8X116
============= Composition/Information on Ingredients =============
Ingred Name:LUBRICATING BASE OIL SEVERLY REFINED PETROLEUM DISTILLATE
CONTAINING ANY MIXTURES OF INGREDIENTS 2-12.
RTECS #:9999999ZZ
Fraction by Wt: >80.0%
OSHA PEL:5 MG/M3 MIST
ACGIH TLV:5 MG/ME MIST
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATES SOLVENT REFINED (SEVERE)
HEAVY PARAFFINIC
CAS:64741-88-4
RTECS #:PY8040501
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATES, SOLVENT-REFINED
(SEVERE) LIGHT PARAFFINIC
CAS:64741-89-5
RTECS #:PY8041501
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATE, SOLVENT REFINED
(SEVERE), HEAVY NAPHTHENIC
CAS:64741-96-4
RTECS #:PY8040001
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATE, SOLVENT-REFINED (SEVERE)
LIGHT NAPHTHENIC
CAS:64741-97-5
RTECS #:PY8041001
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SOLVENT REFINED RESIDUM
CAS:64742-01-4
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATES, HYDROTREATED (SEVERE)
HEAVY NAPTHENIC
CAS:64742-52-5
RTECS #:PY8035001
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATES, HYDROTREATED (SEVERE)
LIGHT NAPHTHENIC
CAS:64742-53-6
RTECS #:PY8036001
OSHA PEL:MG/M3 (OIL MIST), 5
ACGIH TLV:MG/M3 (OIL MIST), 5
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATES,HYDROTREATED
(SEVERE),HEAVY PARAFFINIC
CAS:64742-54-7
RTECS #:PY8035501
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
Ingred Name:SOLVENT DEWAXED RESIDUAL OIL (PETROLEUM)
CAS:64742-62-7
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATE, SOLVENT - DEWAXED HEAVY
PARAFFINIC (SEVERE SOLVENT-REFINING &/HYDROTREATMENT)
CAS:64742-65-0
RTECS #:PY8038501
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:MINERAL OIL
CAS:72623-83-7
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ADDITIVES INCLUDING INGREDIENT 14.
Fraction by Wt: <20.0%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PHOSPHORODITHIOIC ACID, O,O-D1-C1-14-ALKYL ESTERS, ZINC
SALTS (2:1) (ZDDP)
CAS:68649-42-3
Fraction by Wt: <1.6%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPP DATA: SEVL ZDDPS HAVE BEEN REPORTED TO HAVE WEAK
MUTAGENIC ACTIVITY IN CULTURED MAMMALIAN CELLS BUT ONLY AT(ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15: CONCS THAT WERE TOX TO TEST CELLS. MFR DOES NOT
BELIEVE THERE IS ANY MUTAGENIC RISK TO WORKERS EXPOSE TO ZDDPS.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC: CONTAM OF OIL W/LOW LEVELS OF CANCER-CAUSING
COMBUST PRODS OCCURS. USED MOTOR OILS HAVE BEEN SHOWN (ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17: TO CAUSE SKIN CANCER IN MICE FOLLOWING REPEATED
APPLIC & CONTINUOUS EXPOS. BRIEF/INTERMITTENT SKIN CONT(ING 19)
RTECS #:9999999ZZ
Ingred Name:ING 18: W/USED MOTOR OIL IS NOT EXPECTED TO HAVE SERIOUS
EFTS IN HUMANS IF OIL IS THORO REMOVED BY WASHING W/(ING 20)
RTECS #:9999999ZZ
Ingred Name:ING 19: SOAP & WATER. SEE CHEVRON MSDS NO. 1793 FOR ADDTNL
INFORMATION ON USED MOTOR OIL.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: THIS SUBSTANCE IS NOT EXPECTED TO
CAUSE PRLNGD/SIGNIFICANT IRRIT. SKIN: THIS SUBSTANCE IS NOT
EXPECTED TO CAUSE PRLNGD/SIGNIFICANT IRRIT. HOWEVER, IT SHOULD BE
PRACTICALLY NONTOX IF IT GETS ON SK IN. INGEST: SYSTEMIC TOX OF
SUBSTANCE HAS NOT BEEN DETERMINED. HOWEVER, IS SHOULD BE
PRACTICALLY NON-(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:TOX TO INTERNAL ORGANS IF INGESTED.
INHAL: SYSTEMIC TOX OF SUBSTANCE HAS NOT BEEN DETERMINED. HOWEVER,
IT SHOULD BE PRACTICALLY NON-TOXIC TO INTERNAL ORGANS IF INHALED.
PRLNGD/RPTD BRTHG OF P ETRO OIL MIST CAN CAUSE RESP IRRIT. SIGNS &
SYMPTOMS OF OVEREXP: RESP TRACT IRRIT MAY INCL, BUT MAY NOT BE
LIM(SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH W/FRESH WATER FOR AT LEAST 15 MINS. REMOVE CONT
LENSES IF WORN. SKIN:WASH THORO W/SOAP & WATER. REMOVE & WASH
ADVICE. CONSULT M ED PERS BEFORE INDUCING VOMIT. IF MED ADVICE
CANNOT BE OBTAINED, TAKE PERS & PROD CNTNR TO NEAREST MED EMER
TREATMENT CENTER HOSP. INHAL: MOVE TO FRESH AIR. SEE MD IF
DISCOMFORT/IRRIT CONTINUES.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:401F,205C
Extinguishing Media:CO*2, DRY CHEMICAL, FOAM, WATER FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT.
Unusual Fire/Explosion Hazard:NORM COMBUST FORMS CARBON DIOXIDE & WATER
VAPOR & MAY PRODUCE OXIDES OF SULFUR, NITROGEN, PHOSPHORUS & BORON.
INCOMP COMBUST CAN PRODUCE CARBON MONOXIDE.
================== Accidental Release Measures ==================
Spill Release Procedures:STOP SOURCE OF LEAK/RELEASE. CLEAN UP RELEASES
AS SOON AS POSS. CNTN LIQ TO PVNT FURTHER CONTAM OF SOIL, SURF
WATER/GROUNDWATER. CLEAN UP SMALL SPILLS USING APPROP TECHNIQUES
SUCH AS SORBENT MATLS/PUM PING. WHERE FEASIBLE & APPROP, REMOVE
(SUPDAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT WELD, HEAT/DRILL CNTNR. RESIDUE
MAY IGNITE W/EXPLOS VIOLENCE IF HEATED SUFFICIENTLY.
Other Precautions:CAUTION! DO NOT USE PRESS TO EMPTY DRUM/DRUM MAY
RUPTURE W/EXPLO FORCE. THIS PROD CNTNS PETROLEUM BASE OILS WHICH
MAY BE REFINED BY VARIOUS PROCS INCLG SEV SOLV EXTRACTION, SEV
HYDROCRACKING/SEV HYDRO TREATING. DURING USE IN ENGINES(ING 17)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NO SPECIAL RESPIRATORY PROT IS NORMALLY REQD.
HOWEVER, IF OPERATING CNDTNS CREATE HIGH AIRBORNE CONCS, THE USE OF
A NIOSH/MSHA APPROVED RESPIRATOR IS RECOMMENDED.
Ventilation:USE ADEQ VENT TO KEEP AIRBORNE CONCS OF THIS MATL BELOW
RECOMMENDED EXPOSURE STANDARD.
Other Protective Equipment:EMERGENCY EYEWASH & DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA. PROTECTIVE CLOTHING.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
SPEC GRAV: 0.89 @ 15.6/15.6C. SPILL PROC: CONTAMD SOIL. FOLLOW
PRESCRIBED PROCEDURES FOR REPORTING AND RESPONDING TO LARGER
RELEASES. EFTS OF OVEREXP: TO, ONE/MORE OF FOLLOWING: NASAL
DISCHARGE, SORE THROAT, COUGHING, BRONCHITIS, PULM EDEMA & DFCLTY
IN BRTHG. THIS PROD CNTNS ZINC ALKYL DITHIOPHOSPHATES(ZDDPS).(ING
15)
================== Physical/Chemical Properties ==================
Spec Gravity:SUPDAT
Solubility in Water:INSOLUBLE
Appearance and Odor:DARK BROWN LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MAY REACT WITH STRONG OXIDIZING AGENTS, SUCH AS CHLORATES, NITRATES,
PEROXIDES, ETC.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:PLACE CONTAMD MATLS IN DISP CNTNRS & DISP OF IN
MANNER CONSISTENT W/APPLIC REGS. CONT LOCAL, STATE & FEDERAL
ENVIRON/HEALTH AUTHS FOR APPROVED DISP OF THIS MATERIAL.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:DAIRY CATTLE INSECTICIDE
CAGE:DO229
CAGE:18873
CAGE:DO229
============= Composition/Information on Ingredients =============
Ingred Name:METHOXYCHLOR (SARA III)
CAS:72-43-5
RTECS #:KJ3675000
Fraction by Wt: 50.0%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3; 9293
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:INERT INGREDIENTS (TYPE NOT SPECIFIED); WT % BY DIFFERENCE
Fraction by Wt: 50.0%
===================== Hazards Identification =====================
Effects of Overexposure:NONE NOTED BY MFR. LOW TOXICITY & LOW HAZARD TO
HEALTH.
======================= First Aid Measures =======================
First Aid:SKIN:WASH WITH SOAP AND WATER. EYES: FLUSH WITH WATER.
INHALED: REMOVE TO FRESH AIR. REMOVE CONTAMINATED CLOTHING.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:SM:DRY CHEM., CO*2,H*2O SPRAY,FOAM,LG:H*2O
SPRAY,FOG OR FOAM
Fire Fighting Procedures:WEAR SCBA,COOL EXPD CONTRS W H*20. H*20 INEFF
ON FIRE.
Unusual Fire/Explosion Hazard:FINE DUST DISPERSED IN AIR(PARTCULRLY IN
CLOSD AREA)MAY IGNITE IF EXPSD TO HIGH TEMP IGNITION SOURCE
================== Accidental Release Measures ==================
Spill Release Procedures:DO NOT TOUCH SPILLED MATL.REMOVE IGN
SOURCES.EVACUATE UNPROTECTD PERSONS.USE APPROPRIATE PROTECTV
EQUIP.CLEAN UP PROMPTLY;DO NOT FLUSH WITH WATER;PICK UP DRY BY
SWEEPING OR OTHER EFFECTIVE MEANS & PLA CE IN CLOSED CONTAINERS FOR
LATER DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOLK DRY VENTILATED ARE.KEEP
CONTAINERS CLOSED.WASH THOROUGHLY AFTER HANDLING.
Other Precautions:KEEP OUT OF REACH OF CHILDREN;UNUSUAL FIRE HAZ:MAY BE
IGNITD BY HEAT/OPEN FLAME.THESE COND ARE UNLIKELY TO OCCUR IN
OUTDOOR USE OF THIS PRODUCT;PER MFR,LOWER EXPLOSV LIMIT:0.21G/LITER
AIR.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE REQD.USE APPRVD SELF-CONTND
BREATHG APP IF NEEDED
Ventilation:MECH(GEN)OR LOCAL EXHAUST THAT PROVIDES ADEQUATE
VENTILATION
Other Protective Equipment:AS REQUIRED TO PREVENT PROLONGED CONTACT.
Supplemental Safety and Health
SPECIAL FIRE FIGHTG:IF AREA IS HEAVLY EXPOSD TO FIRE & IF CONDITIONS
PERMIT,LET IT BURN OUT SINCE WATER MAY INCREASE THE CONTAMINATION
HAZARD IF CONDITIONS DO NOT PERMIT,USE WATER SPRAY.
================== Physical/Chemical Properties ==================
HCC:T5
Spec Gravity:0.2243
Solubility in Water:DISPERSIBLE
Appearance and Odor:TAN POWDER
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:HEAT, IGNITION SOURCES
Hazardous Decomposition Products:CHLORINE,HCL GAS,CO,CO*2
Conditions to Avoid Polymerization:UNKNWON
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW APPLICABLE(LOCAL,STATE,&/OR
FEDERAL)REGULATIONS;IF BURIED,USE AREA AWAY FM ROOTS
TREES/PLANTS;DISPOSAL SITE SHOULD BE ON LEVEL GRD & NOT NEAR TO
STREAM,PONDS,LAKES,WELLS OR DITCHES.DO N OT RE-USE CONTAINER,BURY
WHEN EMPTY.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:ACETYLENE;ETHYNE
CAGE:0MN39
CAGE:0MN39
============= Composition/Information on Ingredients =============
Ingred Name:ACETYLENE
CAS:74-86-2
RTECS #:AO9600000
Fraction by Wt: >99%
Other REC Limits:NONE RECOMMENDED
ACGIH TLV:ASPHYXIANT; 9596
Ingred Name:OTHER IMURITIES:TRACES OF AIR, PHOSPHINE, ARSINE,HYDROGEN
SULFIDE.
Fraction by Wt: NP
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NARCOTIC GAS/INTOXICANT CAUSES
HYPERCAPNIA(EXCESSIVE AMT OF CO2 IN BLOOD).REPEATED EXPO TO
TOLERANCE LEVES HASN'T SHOWN DELETERIOUS EFECTS.MAJ PROP:EXCLUSION
OF ADEQUATE OXY SUPPLY TO LUNGS.INHAL:SIMP LE
ASPHYXIANT/NARCOTIC.SKIN/EYE:NO ADVERSE EFFECTS HAVE BEEN REPO FRM
PURE GAS.INGEST:NOT LIKELY.
Explanation of Carcinogenicity:PER MSDS:CARCINOGEN STATUS:NONE.
Effects of Overexposure:ACETYLENE LEVEL OF 2.5% NONTOXIC.10%
LEVEL:REVERS NARCOSIS.20%:DYSPNEA,HEAD,STAG GAI.30%:LOSS OF
COORDINATION.33-35%:UNCONSC.UP TO 80%:COMPLETE ANESTHESIA,INCR
BLOOD PRESS,NARC,STIMULATED RESP.MILD GA STRIC SYMPT,DIZZ,MENTAL
CONFUS,EMOTIONAL INSTABILITY,HYPERCAPNIA,MYOCARDIAL
SENS,ASPHYXIATION,RAPID RESP,AIR HUNGER,ETC.
Medical Cond Aggravated by Exposure:PERSONS IN ILL HEALTH WHERE SUCH
ILLNESS WOULD BE AGGRAVATED BY EXPO TO ACETYLENE SHOULD NOT BE
ALLOWED TO WORK W/OR HNDL PROD. TRAGET EFFECTS:SIMPLE
ASPHYXIANT;CNS DEPRESS.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR IMMED.STOP BREATH GIVE ART
RESP.TREAT SYMPT/SUPP.ADMIN OXY IF AVIALABLE BY QUAL PERSON.GET MED
ATTN IMMED.SKIN/EYE/INGEST:UNLIKELY EMERG TREAT WILL BE
REQUIRED.ADVERSE EFFECT S OCCUR WASH SKIN W/LG AMTS OF
WATER/SOAP;WASH EYE W/WATER/NORMAL SALINE;INGEST-TREAT
SYMPT/SUPP;IN ALL CASES GET MED ATTN.NO SPECIFIC ANTIDOTE.TREAT
SYMPTOMATICALLY/SUPPORTIVELY.
===================== Fire Fighting Measures =====================
Flash Point:NOT PROVIDED
Autoignition Temp:Autoignition Temp Text:581F
Lower Limits:2.5
Upper Limits:100
Extinguishing Media:DRY CHEMICAL,CARBON DIOXIDE,HALON. LG FIRES:USE
WATER SPRAY,FOG OR STD FOAM.
Fire Fighting Procedures:MOVE CNTNR FRM FIRE AREA.STAY AWAY FRM STORAGE
TK ENDS.MASSIVE FIRE IN STORAGE AREA USE UNMANNED HOSE
HOLDER/MONITOR NOZZ ELSE W/D FRM AREA,LET FIRE BURN.(SUPP)
Unusual Fire/Explosion Hazard:DANGEROUS EXPLOSION HAZ WHEN EXPO TO
HEAT/FLAME.VAP/AIR MIXTURES EXPLO.DUE TO MATL LOW
ELECTROCONDUCTIVITY FLOW/AGITTION MAY GENERATE ELECTROSTATIC
CHARGES(SUP)
================== Accidental Release Measures ==================
Spill Release Procedures:SHUT OFF IGN SOURCES.STOP LEAK W/O RISK.USE
WATERSPRAY TO REDUCE VAP.ISOLATE AREA TIL GAS HAS DISPERSED.NO
SMOKEING/FLAMES/FLARES IN HAZ AREA.KEEP UNNECESSARY PEOPLE
AWAY;ISOLATE/DENY ENTRY.VENTI CLSDSPACES BEF ENTERING.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:OBSERVE ALL FED/STATE/LOC REGS WHEN
STORING PROD.FOR ASSIST CONTACT DISTRICT DIR OF EPA.STORE IAW
29CFR1910.102.PROTECT AGAINST PHYS DMG.STORE UPRIGHT
Other Precautions:OUTSIDE/DETACHED STORAGE PREF.ISOLATE FROM OXIDZI
GASES ESPECIALLY CL2.STORE IN COOL WELL VENTI NONCOMBUST PLACE AWAY
FROM ALL POSSIBLE IGN SOURCES/COMBUST MATLS.PROTECT AGAINST
LIGHTING/STATIC ELECT. CNTNRS MEET BOND/GROUND NFPA 77-1983.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SPEC RESP SELECTED MSUT BE BASED ON CONTAMIN
LEVELS IN WORKPLACE,NOT EXCEED WORKING LEIMITS OF RESP,APPROVED BY
NIOSH/MSHA.
Ventilation:PROVIDE LOC EXHAUST OR GENERAL DILUTION VENTILATION.
VENTILATION EQPMT MUST BE EXPLOSION-PROOF.
Other Protective Equipment:IMPERVIOUS LCOTHING NOT REQUIRED.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIREFIGHT:W/D IMMED IN CASE OF RISING SOUND FRM VENTING SAF
DEVICE/DISCOLOR OF STORAGE TK FRM FIRE.LET STORAGE VESS BURN UNLESS
LEAK CAN BE STOP.SM TK/CYL EXT/ISOLATE FRM OTHER FLAMM MATL.USE H2O
IN F LOOD AMTS AS FOG.COOL CNTNR W/FLOOD AMTS OF H2O. FIRE/EXPLO
HAZ:RESULTING IN SPARKS W/POSSIBLE IGN.
================== Physical/Chemical Properties ==================
HCC:G2
Boiling Pt:B.P. Text:NP
Melt/Freeze Pt:M.P/F.P Text:-119F,-84C
Decomp Temp:Decomp Text:NP
Vapor Pres:760 @-84C
Vapor Density:1.1747 @0C
Spec Gravity:0.610 @-81C
pH:NP
Viscosity:NP
Evaporation Rate & Reference:NP
Solubility in Water:0.94 @25C, SLIGHT
Appearance and Odor:COLORLESS GAS WTIH ETHEREAL ODOR WHEN PURE,
GARLIC-LIKE ODOR IF IMPURE.
Percent Volatiles by Volume:NP
Corrosion Rate:NP
================= Stability and Reactivity Data =================
BR2;BRASS
W/>65%CU;CL2;CO;CU/SALTS;FL2;I2;HG/SALTS;HNO3;NO;OZONE;OX2;OXIDIZER
S;MOLTEN K;AG/SALTS;AGNO3;NAH;RBH.
Stability Condition to Avoid:MAY DECOMPO EXPLO @ELEVATED
TEMP/PRESS.AVOID CONTACT W/HEAT/SPARK/FLAMES/IGN SOURCES.AVOID
LINE/SYS PRESS >15PSIG.
Hazardous Decomposition Products:THERMAL DECOMPOSITION PRODUCTS MAY
INCLUDE TOXIC OXIDES OF CARBON.
Conditions to Avoid Polymerization:MAY POLYMERIZE EXOTHERMICALLY ON
CONTACT W/APPROPRIATE CATALYSTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:OBSERVE ALL FED/STATE/LOC REGS WHEN DISPO
SUBSTANCE.FOR ASSIST CONTACT DISTRICT DIR OF EPA.
| 0 |
gloves_not_mandatory
|
===================== Product Identification =====================
Product ID:FILLER 8069
Preparer's Name:BILL MCDONALD
CAGE:0FSN9
CAGE:0FSN9
============= Composition/Information on Ingredients =============
Ingred Name:GLASS OXIDE, FIBER GLASS WOOL, LEAD BOROSILICATE GLASS
ENAMEL FLUX
CAS:65997-17-3
Fraction by Wt: >98%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: IRRITATION OF UPPER
RESPIRATORY TRACT, MOUTH/NOSE & THROAT. SKIN/EYES: MAY PRODUCE
TEMPORARY MECHANICAL IRRITATION. INGESTION: TEMPORARY MECHANICAL
IRRITATION OF THE DIGESTIVE TRACT.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, ITCHING
Medical Cond Aggravated by Exposure:PERSONS W/HISTORY OF CHRONIC
RESPIRATORY/SKIN CONDITIONS.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH FOR 15 MINS W/COPIOUS AMOUNTS OF WATER. SKIN:
WASH W/MILD SOAP & RUNNING WATER. USE A WASHCLOTH TO HELP REMOVE
FIBERS. DON'T RUB/SCRATCH AREA. INGESTION: OBSERVE INDIVIDUAL.
INHALATION: MO VE TO FRESH AIR. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER, FOAM, CO2, DRY CHEMICAL
Fire Fighting Procedures:WEAR SELF CONTAINED BREATHING APPARATUS
PRESSURE-DEMAND, MSHA/NIOSH APPROVED & FULL FIRE PROTECTIVE
CLOTHING/GEAR WHEN THERE IS A SUSTAINED FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:FOR DUSTS & FIBERS GENERATED DURING
FABRICATION, VACUUM UP & CONTAINERIZE. AVOID SWEEPING/USING
COMPRESSED AIR AS THESE TECHNIQUES MAY INTRODUCE DUSTS & FIBERS
INTO THE AIR.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID UNNECESSARY EXPOSURES TO DUSTS &
FIBERS. USE VACUUM EQUIPMENT TO REMOVE FIBERS & DUSTS FROM
CLOTHING.
Other Precautions:KEEP THE WORK AREA CLEAN OF DUSTS & FIBERS GENERATED
DURING FABRICATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:A PROPERLY FITTED NIOSH/MSHA APPROVED DISPOSABLE
DUST RESPIRATOR, 3MMODEL 8710/9900 SHOULD BE USED. USE WHEN HIGH
DUST LEVELS ARE ENCOUNTERED; THE LEVEL OF GLASS IN THE AIR EXCEEDS
THE OSHA PEL.
Ventilation:GENERAL DILUTION/LOCAL EXHAUST SHOULD BE PROVIDED, AS
NECESSARY, TO MAINTAIN EXPOSURES BELOW OSHA'S PEL.
Other Protective Equipment:LOOSE FITTING, LONG SLEEVED SHIRT THAT
COVERS TO THE BASE OF THE NECK & LONG PANTS.
Work Hygienic Practices:REMOVE/LAUNDER WORK CLOTHES SEPARATELY. WIPE
OUT WASHER/SINK TO PREVENT LOOSE FIBERS FROM GETTING ON OTHER
CLOTHES.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Spec Gravity:1.96
Solubility in Water:INSOLUBLE
Appearance and Odor:WHITE/OFF WHITE COLORED SOLID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:CO, CO2, HYDROCARBONS, WATER
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:LOW HYDROGEN MARC-ROD E7018 (SEE SUPPLEMENTAL)
CAGE:1EH33
CAGE:1EH33
CAGE:050Q3
============= Composition/Information on Ingredients =============
Ingred Name:IRON (FE)
CAS:7439-89-6
RTECS #:NO4565500
Fraction by Wt: <10.0%
Other REC Limits:NONE RECOMMENDED
Ingred Name:LIMESTONE &/OR CALCIUM CARBONATE
CAS:1317-65-3
RTECS #:EV9580000
Fraction by Wt: <15.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9596
Ingred Name:TITANIUM (TI) DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: <5.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9596
Ingred Name:MANGANESE COMPOUND (UNSPECIFIED); MANGANESE (MN) 7/OR
MANGANESE ALLOYS
Fraction by Wt: <5.0%
Other REC Limits:NONE RECOMMENDED
Ingred Name:BAUXITE &/OR ALUMINUM OXIDE
Fraction by Wt: <1.0%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SILICON (SI) & SILICON ALLOYS
Fraction by Wt: <1.0%
Other REC Limits:NONE RECOMMENDED
Ingred Name:FLUORIDES (F)
Fraction by Wt: <2.0%
Other REC Limits:NONE RECOMMENDED
Ingred Name:MINERAL SILICATES
Fraction by Wt: <1.0%
Other REC Limits:NONE RECOMMENDED
Ingred Name:CARBON STEEL CORE WIRE
Fraction by Wt: <65.0%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL OF WELDING FUMES & GASES CAN BE
DANGEROUS TO YOUR HEALTH. SHORT-TERM (ACUTE) OVEREXPOSURE TO
WELDING FUMES MAY RESULT IN DISCOMFORT SUCH AS DIZZINESS, NAUSEA,
DRYNESS OR IRRIT OF NOSE/THROAT/EYE S. ARC RAYS CAN INJURE EYE/BURN
SKIN, ELECTRIC SHOCK CAN KILL.
Effects of Overexposure:DIZZINESS, NAUSEA, DRYNESS OR IRRIT OF
NOSE/THROAT/EYES. ARC RAYS:INJURE EYE, BURN SKIN. ELECTRIC SHOCK
CAN KILL.
Medical Cond Aggravated by Exposure:LONG-TERM (CHRONIC) OVEREXPO TO
WELDING FUMES CAN LEAD TO SIDEROSIS(IRON DEPOSITS IN LUNGS) &
BELIEVED TO AFFECT PULMONARY FUNCTION.
======================= First Aid Measures =======================
First Aid:CALL FOR MEDICAL ASSISTANCE. USE FIRST AID PROCEDURES
RECOMMENDED BY AMERCIAN RED CROSS. IF BREATHING IS DIFFICULT GIVE
OXYGEN. IF NOT BREATHING USE CPR.
===================== Fire Fighting Measures =====================
Flash Point:NA
Autoignition Temp:Autoignition Temp Text:NA
Lower Limits:NA
Upper Limits:NA
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP MATERIAL DRY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE RESPIRABLE FUME RESPIRATOR OR AIR SUPPLIED
RESP WHEN WELDING IN CONFINED SPACE OR GENERAL WORK AREA WHERE
LOCAL EXHAUST &/OR VENTILATION DOES NOT KEEP EXPOSURE BELOW
THRESHOLD LIMIT VALUE.
Ventilation:USE PLENTY OF VENTILATION. LOC EXHAU:USE LOCAL EXHAUST IF
AVAILABLE.
Other Protective Equipment:HELMET.WEAR APPROVED HEAD/BODY PROTECTION.
Work Hygienic Practices:WELDERS SHOULD BE ADVISED TO KEEP THEIR HEAD
OUT OF FUMES.
Supplemental Safety and Health
84-041,84-042,84-051,84-052,84-053. HAZ DECOMP PROD:USED.GASEOUS RX
PRODUCTS MAY INCLUDE CARBON MONOXIDE & CARBON DIOXIDE.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:NA
Melt/Freeze Pt:M.P/F.P Text:NA
Decomp Temp:Decomp Text:NP
Vapor Pres:NA
Vapor Density:NA
Spec Gravity:NA
pH:NP
Viscosity:NP
Evaporation Rate & Reference:NA
Solubility in Water:NA
Appearance and Odor:NA
Percent Volatiles by Volume:NA
Corrosion Rate:NP
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:WELD FUME/GAS CAN'T BE CLASSIFIED
SIMPLY.COMPO/QUANT DEPENDENT UPON METAL BEING WELD/PROCEDURES
FOLLOWED/ELECTRODE(SUPP)
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCARD ANY PRODUCT/RESIDUE/DISPOSAL
CONTAINER/LINER IN ENVIRONMENTALLY ACCEPTABLE MANNER APPROVED BY
FED/STATE/LOC REGS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:CALMAGITE,119 7425
CAGE:ACR0S
CAGE:ACR0S
============= Composition/Information on Ingredients =============
Ingred Name:CALMAGITE
CAS:3147-14-6
= Wt:100.
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EXERCISE APPROPRIATE PROCEDURES TO
PREVENT OPPORTUNITIES FOR DIRECT CONTACT WITH THE SKIN OR EYES OR
TO PREVENT INHALATION.
Effects of Overexposure:SEE HEALTH HAZARDS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. TREAT SYMPTOMATICALLY. IF
SYMPTOMS ARE PRESENT GET MEDICAL ATTENTION. SKIN: IMMEDIATELY FLUSH
WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES. GET MEDICAL ATTENTION
IF SY MPTOMS ARE PRESENT AFTER WASHING. EYES: IMMEDIATELY FLUSH
WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES AND GET MEDICAL
ATTENTION. INGESTION: DRINK 1-2 GLASSES OF WATER OR MILK. CALL MD.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER SPRAY, DRY CHEMICAL, CARBON DIOXIDE.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . USE WATER SPRAY TO KEEP FIRE EXPOSED CONTAINERS COOL.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS. THIS MATERIAL IN SUFFICIENT
QUANTITY AND REDUCED PARTICLE SIZE IS CAPABLE OF CREATING A DUST
EXPLOSION.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP MATERIAL AND PACKAGE FOR SAFE FEED TO
AN INCINERATOR.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP FROM CONTACT WITH OXIDIZING
MATERIAL. POTENTIALLY HEAT SENSITIVE. EXERCISE CAUTION IF HEATING
IN A CLOSED VESSEL. STORE IN COOL PLACE. KEEP AWAY FROM FIRE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:A NIOSH APPROVED DUST RESPIRATOR SHOULD BE WORN
IF NEEDED.
Ventilation:GOOD GENERAL ROOM VENTILATION SHOULD BE USED. LOCAL EXHAUST
MAY BE NEEDED.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:NOT AVAILABLE
Vapor Pres:NEGLIGIBLE
Spec Gravity:NOT AVAILABLE (WATER=1)
Evaporation Rate & Reference:NEGLIGIBLE (N-BUAC=1)
Solubility in Water:NOT AVAILABLE (BY WT)
Appearance and Odor:RED CRYSTALLINE SOLID.
Percent Volatiles by Volume:NEGLIG (WT)
================= Stability and Reactivity Data =================
STRONG OXIDIZERS.
Stability Condition to Avoid:NOT FULLY EVALUATED. MATERIALS CONTAINING
SIMILAR FUNCTIONAL GROUPS CAN DECOMPOSE UPON HEATING.
Hazardous Decomposition Products:COMBUSTION WILL PRODUCE CARBON DIOXIDE
AND PROBABLY CARBON MONOXIDE. OXIDES OF NITROGEN AND SULFUR MAY
ALSO BE PRESENT.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
=================== Toxicological Information===================
Toxicological Information:THE TOXICOLOGICAL PROPERTIES OF THIS MATERIAL
HAVE NOT BEEN INVESTIGATED.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE BY INCINERATION OR CONTRACT WITH
LICENSED CHEMICAL WASTE DISPOSAL AGENCY. DISCHARGE, TREATMENT, OR
DISPOSAL MAY BE SUBJECT TO FEDERAL, STATE OR LOCAL LAWS.
======================= Other Information =======================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:922WA,1000 GREEN CONCENTRATE
CAGE:39739
CAGE:39739
CAGE:0EN39
============= Composition/Information on Ingredients =============
Ingred Name:2-BUTOXYETHANOL (BUTYL CELLOSOLVE)
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: 63.7%
Other REC Limits:50 PPM VAPOR
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM; 9293
Ingred Name:ETHYLENE GLYCOL (SARA III)
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: 10.3%
Other REC Limits:50 PPM SKIN
OSHA PEL:C 50 PPM
ACGIH TLV:C 50 PPM,VAPOR; 9293
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 25.7%
Other REC Limits:NONE RECOMMENDED
Ingred Name:GREEN DYE
CAS:518-47-8
RTECS #:LM5425000
Fraction by Wt: TRACE
Other REC Limits:NONE RECOMMENDED
Ingred Name:GREEN DYE
CAS:19381-50-1
RTECS #:LJ8930000
Fraction by Wt: TRACE
Other REC Limits:NONE RECOMMENDED
Ingred Name:AERESOL OT SOLUTION
CAS:577-11-7
RTECS #:WN0525000
Fraction by Wt: 0.3%
Other REC Limits:NONE RECOMMENDED
Ingred Name:VOLATILE ORGANIC CONTENT (739 G/L)
RTECS #:9999999VO
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM BICARBONATE
CAS:144-55-8
RTECS #:VZ0950000
Fraction by Wt: TRACE
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT) IS 726 MG OF MIX/KG.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES: MODERATELY TO SEVERELY
IRRITATING. SKIN: MAY CAUSE REDDENING, SWELLING. PROLONGED CONTACT
MAY CAUSE DAMAGE. INHALATION: VAPORS, MISTS MAY CAUSE LIMITED
IRRITATION, DIZZINESS. INGESTION: M AY CAUSE SEVERE ILLNESS,
INTOXICATION.
Effects of Overexposure:EYES: IRRITATION. SKIN: IRRITATION, REDDENING,
SWELLING. INHALATION: IRRITATION, CNS DEPRESSION, GIDDINESS,
HEADACHE, DIZZINESS, NAUSEA. INGESTION: KIDNEY DAMAGE MAY BE
EVIDENCED BY CHANGES IN URINE O UTPUT, UREA APPEARANCE OR EDEMA.
LIVER DAMAGE EVIDENCED BY LOSS OF APPETITE, JAUNDICE, UPPER ABDOMEN
PAIN ON RIGHT SIDE
Medical Cond Aggravated by Exposure:PREEXISTING SKIN, EYE, RESPIRATORY
DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS PRODUCT.IMPAIRED
KIDNEY AND LIVER FUNCTIONS FROM PREEXISTING DISORDERS MAY BE
AGGREVATED BY EXPOSURE TO THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH LARGE AMOUNTS OF WATER. GET MEDICAL
ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING. FLUSH SKIN WITH
WATER. IF IRRITATION OCCURS, GET MEDICAL ATTENTION. INHALATION:
MOVE TO FRESH AIR. D UE TO HIGH BOILING POINT, INHALATION ISNOT
NORMALLY A PROBLEM. INGESTION: GIVE TWO GLASSES OF WATER AND INDUCE
VOMITING. GET MEDICAL ATTENTION IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLASHING
Extinguishing Media:CARBON DIOXIDE, DRY CHEMCIAL.
Fire Fighting Procedures:USE A SELF-CONTAINED BREATHING APPARATUS
WHENEVER FIGHTING A CHEMICAL FIRE.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH WITH WATER AND CLEAN UP WITH ABSORBENT
MATERIAL. DISPOSE OF PROPERLY.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:THIS PRODUCT IS FOR INDUSTRIAL AND
LABORATORY USE ONLY, KEEP AWAY FROM CHILDREN. DO NOT STORE IN OPEN,
UNLABELED, OR MISLABELED CONTAINERS.
Other Precautions:KEEP AWAY FROM FLAMES AND HIGH TEMPERATURES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT TYPICALLY REQUIRED. IF EXPOSURE EXCEEDS
PERMISSIBLE EXPOSURE LIMITS, WEAR A SELF-CONTAINED BREATHING
APPARATUS IN COMPLIANCE WITH NIOSH/MSHA SPECIFICATIONS. COMPLY WITH
29CFR 1910.134.
Ventilation:GENERAL(MECHANICAL) VENTILATION IS GENERALLY
SATISFACTORY.LOCAL VENTILATION MAY BE NEEDED WHERE VAPORS EXCEED
LIMITS.
Other Protective Equipment:BOOTS,APRONS,CHEMICAL SUITS SHOULD BE USED
WHEN NEEDED TO PREVENT SKIN CONTACT.PROVIDE EYE WASH STATION/SAFETY
SHOWER.
Work Hygienic Practices:WASH HANDS AFTER HANDLING AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:310F,154C
Vapor Pres:20
Vapor Density:<1
Spec Gravity:0.9982
Solubility in Water:COMPLETELY MISCIBLE
Appearance and Odor:GREEN, ODORLESS, LIQUID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDANTS, ALKALIES.
Stability Condition to Avoid:KEEP AWAY FROM FLAMES AND HIGH
TEMPERATURES.
Hazardous Decomposition Products:CARBON MONOXIDE AND UNDEFINED ORGANIC
COMPOUNDS MAY BE FORMED DURING COMBUSTION.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:PLACE IN AN APPROPRIATE DISPOSAL FACILITY IN
COMPLIANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:2750VA JACOBEAN
CAGE:EO256
CAGE:EO256
CAGE:0K1A4
============= Composition/Information on Ingredients =============
Ingred Name:C.I. PIGMENT RED 49 *96-2*
CAS:1103-38-4
Fraction by Wt: 0-1.04%
Ingred Name:SOLVENT NAPHTHA, PETROLEUM, LIGHT AROMATIC, HIGH FLASH
AROMATIC NAPHTHA, C8&10 AROMATIC HYDROCARBON *96-2*
CAS:64742-95-6
RTECS #:WF3400000
Fraction by Wt: 0-3.5%
Ingred Name:KEROSENE (PETROLEUM), HYDROTREATED (C10-C15 SATURATED
HYDROCARBONS 97%, C10 AROMATICS 3%) (SUSP CARC IARC) * 96-2 *
CAS:64742-47-8
RTECS #:OA5504000
Fraction by Wt: 0-9%
Other REC Limits:200 PPM EXXON
Ingred Name:HEAVY ALIPHATIC NAPHTHA *96-2*
CAS:64742-96-7
Fraction by Wt: 15-27%
Other REC Limits:100 PPM
Ingred Name:STODDARD SOLVENT (PETROLEUM DISTILLATE), MINERAL SPIRITS
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 7.5-13%
Other REC Limits:525 MG/CUM
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
Ingred Name:TALC (POWDER), (ASBESTOS FREE), TALCUM; HYDROUS MAGNESIUM
SILICATE
CAS:14807-96-6
RTECS #:WW2710000
Fraction by Wt: 0-4%
OSHA PEL:2 MG/CUM (RESP DUST)
ACGIH TLV:2 MG/CUM (RESP DUST)
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: IRRITATION. INGESTION:
HARMFUL/FATAL. CONTAINS MINERAL SPIRITS. DON'T TAKE INTERNALLY.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. SKIN: WASH THOROUGHLY W/SOAP
& WATER. EYES: FLUSH THOROUGHLY W/WATER, THEN REMOVE ANY CONTACT
LENSES. CONTINUE TO FLUSH W/WATER FOR 15 MINS. INGESTION: DON'T
INDUCE VO MITING. OBTAIN MEDICAL ATTENTION IN ALLCASES.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:135F
Extinguishing Media:WATER SPRAY, FOAM, DRY CHEMICAL/CO2.
Fire Fighting Procedures:DON'T USE DIRECT STREAM OF WATER. PRODUCT WILL
FLOAT & CAN BE REIGNITED ON SURFACE OF WATER. WEAR SCBA &
PROTECTIVE CLOTHING. USE WATER SPRAY TO COOL CONTAINERS
Unusual Fire/Explosion Hazard:COMBUSTIBLE.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL: ABSORB W/SAND/OTHER SUITABLE ABSORBENT
MATERIAL & PLACE IN CONTAINER FOR DISPOSAL. LARGE: MAY BE SLIPPERY,
DIKE W/ABSORBENT MATERIAL. TRANSFER LIQUIDS & CONTAMINATED DIKING
MATERIAL TO SEPARATE , SUITABLE CONTAINERS FOR RECOVERY/DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T USE/STORE NEAR HEAT & OTHER
IGNITION SOURCES. CLOSE CONTAINERS AFTER EACH USE.
Other Precautions:DON'T TAKE INTERNALLY. AVOID CONTACT W/SKIN & EYES.
AVOID INHALATION & USE ONLY W/ADEQUATE VENTILATION. IF USING
INDOORS, OPEN ALL WINDOWS & DOORS TO MAKE SURE THERE IS FRESH AIR
MOVEMENT. KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF ADEQUATE VENTILATION CAN'T BE MAINTAINED,
WEAR RESPIRATORY PROTECTION.
Ventilation:IF USING INDOORS, OPEN ALL DOORS TO MAKE SURE THERE IS
FRESH AIR MOVEMENTS.
Supplemental Safety and Health
APPEARANCE: CLEAR AMBER TO OPAQUE EARTH-TONE, SLIGHTLY VISCOUS LIQUID
W/MILD HYDROCARBON ODOR.
================== Physical/Chemical Properties ==================
Spec Gravity:0.917-0.946
Solubility in Water:INSOLUBLE
Appearance and Odor:(SEE SUPP)
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME & OTHER IGNITION
SOURCES.
Hazardous Decomposition Products:THERMAL: HYDROCARBON FUMES, SMOKE, CO
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:SODIUM CYANIDE
CAGE:DO870
CAGE:DO870
CAGE:70829
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM CYANIDE (SARA III)
CAS:143-33-9
RTECS #:VZ7525000
Fraction by Wt: 90-100%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 (CN)
ACGIH TLV:S; 5 MG/M3 (CN);9192
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL RAT) IS 6.440 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION OF DUST WILL CAUSE
RESPIRATORY TRACT IRRITATION & MAY BE FATAL. DUSTS WILL IRRITATE,
BURN & DAMAGE THE EYES. DUST WILL CAUSE SKIN IRRITATION & RASH.
FATAL AMOUNTS CAN BE ABSORBED THR OUGH THE SKIN. SWALLOWING CAN
CAUSE DEATH. CHRONIC: LOSS OF APPETITE, HEADACHE, WEAKNESS, NAUSEA,
DIZZINESS & IRRITATION
Explanation of Carcinogenicity:THIS PRODUCT IS NOT LISTED BY IARC, NTP,
OR OSHA AS A CARCINOGEN.
Effects of Overexposure:EYE, SKIN & RESPIRATORY TRACT IRRITATION.
PROLONGED OR REPEATED SKIN CONTACT MAY RESULT IN ITCHING RASH
CHARACTERIZED BY MACULAR, POPULAR, AND VESICULAR ERUPTIONS USUALLY
FOLLOWED BY SECONDARY INFECTI ON. CAN CAUSE DEATH THROUGH CHEMICAL
ASPHYXIA. MAY CAUSE HEADACHE, WEAKNESS, NAUSEA, DIZZINESS AND LOSS
OF APPETITE.
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH PRE-EXISTING
DISEASES OF THE CENTRAL NERVOUS SYSTEM MAY HAVE INCREASED
SUSCEPTIBILITY TO THE TOXICITY OF EXCESSIVE EXPOSURES.
======================= First Aid Measures =======================
First Aid:PLAN & PRACTICE ACTIONS TO BE TAKEN IN CASE OF CYANIDE
EXPOSURE BEFORE BEGINNING WORK WITH CYANIDES. IMMEDIATELY GIVE
VICTIM OXYGEN AND AMYL NITRITE WHILE WAITING FOR INTRAVENOUS
INJECTIONS FROM MEDIC AL PERSONNEL. INHALATION: REMOVE TO FRESH
AIR/CPR. EYE: FLUSH WITH PLENTY OF WATER. SKIN: REMOVE CONTAMINATED
CLOTHING & WASH SKIN. INGESTION: GIVE 1% SODIUM THIOSULFATE
SOLUTION & INDUCE VOMITING.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE WATER FOG, FOAM, OR DRY CHEMICAL. DO NOT USE
CARBON DIOXIDE.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED
CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS. GIVES OFF FLAMMABLE
VAPORS. VAPORS FORM EXPLOSIVE MIXTURE WITH AIR.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT & SCBA. SMALL SPILL:
SWEEP UP AND DISPOSE OF IN DOT-APPROVED WASTE CONTAINERS. LARGE
SPILL: SHOVEL INTO DOT-APPROVED WASTE CONTAINERS. KEEP OUT OF
SEWERS, STORM DRAINS, SURFA CE WATERS, AND SOIL. KEEP SPILLAGE DRY.
Neutralizing Agent:FLUSH RESIDUE WITH DILUTE SOLUTION OF SODIUM
HYPOCHLORITE OR HYDROGEN PEROXIDE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY, WELL VENTILATED
AREA. KEEP CONTAINERS TIGHTLY CLOSED WHEN NOT IN USE. DO NOT STORE
NEAR ACIDS, OXIDIZERS, FLAMMABLES OR FOODS.
Other Precautions:DO NOT TAKE INTERNALLY. DO NOT BREATHE DUST. AVOID
CONTACT WITH EYES, SKIN OR CLOTHING. USE WITH ADEQUATE VENTILATION.
WASH THOROUGHLY AFTER HANDLING. FOR INDUSTRIAL USE ONLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF USE CONDITIONS GENERATE DUSTS, WEAR A NIOSH
APPROVED RESPIRATOR APPROPRIATE FOR EMISSION LEVELS. RESPIRATORS
MAY BE A FULL FACEPIECE AIR-PURIFYING CARTRIDGE RESPIRATOR WITH
PARTICULATE FILTERS, A S CBA, OR SUPPLIED-AIR RESPIRATOR.
Ventilation:LOCAL MECHANICAL EXHAUST VENTILATION CAPABLE OF MINIMIZING
DUST EMISSIONS AT THE POINT OF USE.
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER. FIRST
AID AND MEDICAL TREATMENT SUPPLIES INCLUDING OXYGEN RESUSCITATORS.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
CONTAINERS, EVEN THOSE THAT HAVE BEEN EMPTIED, WILL RETAIN PRODUCT
RESIDUE AND VAPORS. ALWAYS OBEY HAZARD WARNINGS AND HANDLE EMPTY
CONTAINERS AS IF THEY WERE FULL.
================== Physical/Chemical Properties ==================
HCC:T2
Boiling Pt:B.P. Text:2725F,1496C
Melt/Freeze Pt:M.P/F.P Text:1047F,564C
Vapor Density:1.7
Spec Gravity:1.6
Solubility in Water:APPRECIABLE
Appearance and Odor:ODORLESS, WHITE SOLID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG MINERAL ACIDS AND WATER.
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES AND OTHER SOURCES
OF IGNITION
Hazardous Decomposition Products:POISONOUS HYDROGEN CYANIDE AND AMMONIA
GASES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL SHOULD BE MADE IN ACCORDANCE WITH ALL
APPLICABLE FEDERAL, STATE AND LOCAL LAWS AND REGULATIONS. NOTE:
EMPTY CONTAINERS CAN HAVE RESIDUES AND ARE SUBJECT TO PROPER WASTE
DISPOSAL REQUIREMENTS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:62-6100 ELECTROPHOTOGRAPHIC DRY TONER(M-980
CAGE:HO951
CAGE:17638
CAGE:HO951
============= Composition/Information on Ingredients =============
Ingred Name:EPOXY/ACRYLATE RESIN
Fraction by Wt: 90.0%
ACGIH TLV:UNK
Ingred Name:CARBON BLACK
RTECS #:FF2500000
Fraction by Wt: 9.7%
ACGIH TLV:3.5 MG/CUM
Ingred Name:EXTENDED PIGMENT
Fraction by Wt: 0.3%
ACGIH TLV:UNK
===================== Hazards Identification =====================
Effects of Overexposure:MAY CAUSE TEMPORARY DISCOMFORT TO EYES.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W WATER.INHAL:REMOVE TO FRESH AIR.INGESTN:INDUCE
VOMITING;CALL PHYSICIAN.
===================== Fire Fighting Measures =====================
Extinguishing Media:CO*2,DRY CHEMICAL
Fire Fighting Procedures:NONE.AVOID CLOUDS OF AIR-BORN DUST &
INHALATION OF DUST.
Unusual Fire/Explosion Hazard:NONE KNOWN
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP OR VACUUM & DISCARD
======================Handling and Storage ======================
Handling and Storage Precautions:NONE KNOWN
Other Precautions:AVOID INHALATION DUST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NORMALLY REQUIRED
Ventilation:NORMAL OFFICE ENVIRONMENT
Other Protective Equipment:NONE KNOWN
Supplemental Safety and Health
MSDS DATED APRIL 28,1981
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:1.15
Solubility in Water:INSOLUBLE
Appearance and Odor:BLACK SOLID/POWDER,FAINT ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATL.
Stability Condition to Avoid:UNK
Hazardous Decomposition Products:CO
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN NORMAL MANNER FOR BURNABLE
DUST-LIKE MATERIAL IAW LOCAL,STATE,FED REGS.
| 0 |
gloves_not_mandatory
|
===================== Product Identification =====================
Product ID:2304 MARA SOL
CAGE:SEAFR
CAGE:SEAFR
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM CARBONATE (SODA ASH, TRONA, CARBONIC ACID, CRYSTOL
CARBONATE, DISODIUM CARBONATE)
CAS:497-19-8
RTECS #:VZ4050000
Ingred Name:DODECYLBENZENESULFONIC ACID (DDBSA), BENZENESULFONIC ACID
CAS:27176-87-0
RTECS #:DB6600000
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:COCAMIDE DIETHANOLAMINE *92/2*
CAS:61791-31-9
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN: IRRITATION. INGESTION:
HARMFUL.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES/SKIN: IRRITATION. INGESTION: HARMFUL.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MINS. SKIN:
WASH W/SOAP & WATER. INHALATION: REMOVE TO FRESH AIR. INGESTION:
OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:FOAM, CO2, DRY CHEMICAL
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB W/INERT MATERIAL & TRANSFER TO
CONTAINERS FOR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY AREA. KEEP
CONTAINERS CLOSED WHEN NOT IN USE.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. AVOID INHALATION OR
INGESTION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IN HIGH VAPOR CONCENTRATION USE A SELF-CONTAINED
BREATHING APPARATUS.
Ventilation:LOCAL EXHAUST ONLY IF MECHANICAL IS INADEQUATE
Other Protective Equipment:EYE WASH STATION
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE. WASH HANDS
BEFORE EATING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F
Spec Gravity:1.030
Solubility in Water:COMPLETE
Appearance and Odor:PINK-RED CLEAR VISCOUS LIQUID W/SLIGHT DETERGENT
ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:M-PYROL HP 150 DIAZO SOLVENT ERADICATOR
CAGE:HAMPT
CAGE:HAMPT
============= Composition/Information on Ingredients =============
Ingred Name:2-PYRROLIDINONE, 1-METHYL-; (N-METHYLPYRROLIDONE)
CAS:872-50-4
RTECS #:UY5790000
Fraction by Wt: 99.5%
ACGIH TLV:100 PPM (MFR)
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50: (ORAL,RAT) 42000 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL: RAT AT SUPER SATURATED 110C
CONC, NO EVIDENCE OF TOXIC EFFECTS. SKIN IRRITATION: MILD
IRRITATION IN THE RABBIT, HOWEVER HUMAN EXPERIENCE HAS DEMONSTRATED
SEVERE DERMATITIS E.G., BLISTERS, CRACK ING EDEMA, REDNESS UPON
PROLONGED OR REPEATED CONTACT. EYE IRRIT: HUMAN REPEAT INSULT PATCH
TEST (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:MILD TRANSIENT IRRIT THRU RPTD PRLNGD
CNTCT MATL WAS FOUND TO BE A FATIGUING AGENT BUT NOT A SENSIT.
SIGNS & SYMPS: INGEST:NO EFTS OF EXPOS EXPECTED. INHAL:NO EFTS OF
EXPOS EXPECTED. IN VERY HIGH CONC ONLY - HDCH, GIDDINESS, MENTAL
CONFUSION, NAUS. EYES: VAPS SLIGHTLY UNCOMFORTABLE SPLASHES IRRIT.
(SUPP DATA)
Medical Cond Aggravated by Exposure:NO DATA FOUND.
======================= First Aid Measures =======================
First Aid:INGEST: GEN PREC MEASURES SUGGEST INDUCING VOMIT IMMED BY
GIVING TWO GLASSES OF WATER & STICKING FINGER DOWN THROAT. NEVER
GIVE ANYTHING BY MOUTH TO AN UNCON PERSON. CALL MD. INHAL: REMOVE
TO FRESH AI R. IF NOT BRTHG, GIVE ARTF RESP PREFERABLY
MOUTH-TO-MOUTH. IF BRTHG IS DFCLT GIVE O*2. CALL MD. SKIN:FLUSH
SKIN W/WATER. EYE:IMMED FLUSH EYES W/PLENTY OF H*2O FOR @ LST 15
MIN. CALL MD.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:199F,93C
Lower Limits:1.30 %
Upper Limits:9.5%
Extinguishing Media:WATER, ALCOHOL FOAM, DRY CHEMICAL, CARBON DIOXIDE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:MODERATE HAZARD WHEN EXPOSED TO HEAT OR
FLAME.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE SOURCES OF IGNITION. ABSORB WITH
EARTH SAND OR SIMILAR INERT MATERIAL AND DISPOSE OF WITH SOLID
WASTE ACCORDING TO FEDERAL, STATE AND LOCAL REGULATIONS. FLUSH
SPILL AREA WITH WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTACT W/EYES & SKIN. AVOID
BRTHG VAPOR. USE WITH ADEQUATE VENTILATION. KEEP THIS CONTAINER AND
VAPORS FROM THIS CNTNR AWAY FROM HEAT/FLAME.
Other Precautions:KEEP CONTAINER CLOSED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:USE WITH ADEQUATE VENTILATION.
Other Protective Equipment:WASH EQUIP THORO W/STEAM OR WARM WATER UNTIL
CLEAN. CHECK FOR FLAMMABLES W/AN EXPLOSION METER AND ALSO CHECK
(SUPP DATA)
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
PH:10% SOLN SLIGHTLY ALKALINE. EFTS OF OVEREXP:WILL CAUSE PAINFUL
BURNING/STINGING OF EYES & LIDS. WATERING OF EYES & INFLAMM OF
CONJUNCTIVA. SKIN:PRLNGD/RPTD CNTCT CAN CAUSE REDNESS, SWELLING,
CRACKI NG. OTHER PROT EQUIP:THE OXYGEN LEVEL W/OXYGEN METER. IN ALL
CASES FOLLOW GOOD INDUST SFTY PRACT BEFORE ENTERING EQUIP.
================== Physical/Chemical Properties ==================
HCC:V4
Boiling Pt:B.P. Text:396F,202C
Melt/Freeze Pt:M.P/F.P Text:75.2F,24.0C
Vapor Pres:0.29 @ 20C
Vapor Density:3.40
Spec Gravity:1.0270(H*2O=1)
pH:SUPDAT
Evaporation Rate & Reference:0.06 (BU ACET=1)
Appearance and Odor:WATER-LIKE LIQUID. MILD AMINE-LIKE ODOR.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING OR REDUCING AGENTS.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:CO AND NO*X FUME EMITTED WHEN HEATED
TO DECOMPOSITION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF WITH LIQUID WASTE ACCORDING TO
FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:MOUNTING MEDIUM
Preparer's Name:DOD-HMIS (DGSC-SSH)
CAGE:65554
CAGE:65554
============= Composition/Information on Ingredients =============
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 40%*
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III) *THE SOLVENT FOR
THE MOUNTING MEDIUM MAY BE EITHER TOLUENE OR XYLENE, NOT BOTH.*
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 40%*
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:RESIN
Fraction by Wt: 60%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:PER DEFENSE MEDICAL PURCHASE
DESCRIPTION, PRODUCT CONTAINS TOLUENE OR XYLENE AS THE SOLVENT.
INHALING THE FUMES IS THE MOST LIKELY HAZARD. INHALING THESE FUMES
WILL CAUSE CNS DEPRESSION, DIZZINESS, HE ADACHE, ETC.
INTENTIONALLY CONCENTRATING THEM MAY BE HARMFUL. CHRONIC
OVEREXPOSURE CAUSES CNS DAMAGE.
Explanation of Carcinogenicity:RESIN PORTION OF THE MEDIUM IS UNKNOWN,
BUT IS NOT EXPECTED TO CONTAIN ANY CARCINOGENS.
Effects of Overexposure:OVEREXPOSURE MAY LEAD TO RESPIRATORY
IRRITATION, NAUSEA, FATIGUE, DIZZINESS, HEADACHES, UNCONSCIOUSNESS.
SKIN CONTACT MAY CAUSE DERMATITIS.EYE CONTACT CAUSES IRRITATION.
Medical Cond Aggravated by Exposure:PERSONS WITH A SKIN DISORDER SHOULD
USE CAUTION WHEN HANDLING OR USING THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH W/WATER 15 MIN, HOLD LIDS OPEN. SKIN:WASH WITH SOAP
& WATER. REMOVE CONTAMINATED CLOTHING AND LAUNDER BEFORE REUSE.
INHALED:REMOVE TO FRESH AIR. RESTORE BREATHING IF NECESSARY.
INGESTED:DO N OT INDUCE VOMITING. GIVE 2 LARGE GLASSESOF MILK OR
WATER AND GET IMMEDIATE MEDICAL CARE. DOCTOR TO ORDER VOMITING.
NOTHING BY MOUTH IF UNCONSCIOUS. IF IRRITATION PERSISTS OR IS
SEVERE,SEE A DOCTOR.
===================== Fire Fighting Measures =====================
Flash Point:EST. 45.0F,7.2C
Extinguishing Media:USE CARBON DIOXIDE, FOAM, DRY CHEMICAL, OR WATER
FOG.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY CAUSE
PRODUCTION OF HAZARDOUS DECOMPOSITION PRODUCTS.
================== Accidental Release Measures ==================
Spill Release Procedures:WIPE UP SPILLED MATERILA WITH PAPER OR CLOTH.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, VENTILATED WORK AREA.
KEEP CONTAINERS CLOSED WHEN NOT IN USE. FLAMMABLE LIQUID, EMPTY
CONTAINERS CAN BE HAZARDOUS.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESPIRATOR WILL NOT NORMALLY BE NECESSARY. USE
NIOSH/MSHA APPROVED AIR SUPPLIED RESPIRATOR OR RESPIRATOR FOR
ORGANIC VAPORS IF EXPOSURE IS ABOVE THE TLV/PEL. SEE 29 CFR
1910.134 FOR REGULATIONS PERTA INING TO RESPIRATOR USE.
Ventilation:NOT NORMALLY REQUIRED. USE LAB HOOD OR OTHER LOCAL EXHAUST
TO MAINTAIN EXPOSURE BELOW PEL/TLV.
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER, LAB COAT
OR APRON TO PROTECT EXPOSED SKIN.
Work Hygienic Practices:USE GOOD CHEMICAL HYGIENE PRACTICE. AVOID
UNNECESSARY CONTACT. WASH THOROUGHLY BEFORE EATING OR DRINKING.
Supplemental Safety and Health
ACE SCIENTIFIC IS OUT OF BUSINESS. THIS MSDS WRITTEN AROUND DPSC
PURCHASE DESCRIPTION.
================== Physical/Chemical Properties ==================
HCC:F2
Solubility in Water:NEGLIGIBLE
Appearance and Odor:YELLOW LIQUID
Percent Volatiles by Volume:40
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH TEMPERATURES, SPARKS, AND OPEN FLAMES
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE AND
OTHER HYDROCARBON COMPOUNDS DURING COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE I/A/W ALL FEDERAL, STATE AND LOCAL
REGULATIONS. MANUFACTURER SUGGESTS THAT DISPOSAL MAY BE DONE BY
| 1 |
gloves_mandatory
|
=======================================================
NIIN: 01-412-2434
Product ID: SUPERIOR SNO-N-ICE MELTER
Cage: 7X475
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 7X475
=======================================================
Item Description Information
=======================================================
Item Manager: GSA
Item Name: DEICER
Unit of Issue: BX
Quantitative Expression: 00000000050LB
UI Container Qty: 1
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: EYE IRRITANT. MAY IRRITATE SENSITIVE SKIN. MAY BE HARMFUL
IF SWALLOWED ESPECIALLY IN LARGE AMOUNTS BECAUSE OF SMALL QUANITIES OF
ALKALINE SALTS.
First Aid: EYES: FLUSH W/WATER. IF IRRITATION OR REDNESS ARE SEVERE OR PERSIST,
CALL DOCTOR. SKIN: WASH OFF W/WATER. INGESTION: DRINK LIQUIDS TO DILUTE AND
CALL DR.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: SMALL SPILLS MAY BE FLUSHED AWAY W/WATER OR SWEEP UP.
SWEEP OR SCRAPE UP LARGE SPILLS FOR REUSE OR DISPOSAL.
Waste Disposal Methods: SMAIL SPILLS MAY BE SEWERED. LARGE SPILLS SHOULD BE
DISPOSED OF IN LANDFILL ACCORDING TO REGULATIONS.
=======================================================
Fire and Explosion Hazard Information
=======================================================
=======================================================
Control Measures
=======================================================
=======================================================
Physical/Chemical Properties
=======================================================
Solubility in Water: SOLUBLE
Appearance and Odor: RED, CRYSTALINE, SOLID.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Materials To Avoid: STRONG OXIDIZING AGENTS.
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
Transportation Information
=======================================================
Trans ID NO: 134837
Product ID: SUPERIOR SNO-N-ICE MELTER
Review Date: 10/03/1996
Multiple KIT Number: 0
Review IND: Y
Unit Of Issue: BX
Container QTY: 1
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: ZZZ
DOT Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: ZZZ
IMO Proper Shipping Name: NOT REGULATED FOR THIS MODE OF TRANSPORTATION
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: ZZZ
IATA Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: ZZZ
AFI Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
HAZCOM Label
=======================================================
Product ID: SUPERIOR SNO-N-ICE MELTER
Cage: 7X475
Company Name: CP INDUSTRIES
Street: 503 N 400 W
Zipcode: 84103-1311
Label Required IND: Y
Date Of Label Review: 10/12/1999
Status Code: A
Origination Code: G
Hazard And Precautions: EYE IRRITANT. MAY IRRITATE SENSITIVE SKIN. MAY BE
HARMFUL IF SWALLOWED ESPECIALLY IN LARGE AMOUNTS BECAUSE OF SMALL QUANITIES
OF ALKALINE SALTS.
=======================================================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:CIM 1061 ACTIVATOR
Preparer's Name:RH STEPHENS
CAGE:CIMIN
CAGE:CIMIN
============= Composition/Information on Ingredients =============
Ingred Name:DIPHENYLMETHANE 4,4'-DIISOCYANATE (MDI)
CAS:101-68-8
RTECS #:NQ9350000
Minumum % Wt:0.
Maxumum % Wt:80.
Other REC Limits:N/K
OSHA PEL:C0.2 MG/M3;C0.02 PPM
OSHA STEL:N/K
ACGIH TLV:0.051 MG/M3;.005 PPM
ACGIH STEL:N/K
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:BENZENE, 1,1'-METHYLENEBIS.(.ISOCYANATO-, HOMOPOLYMER;
(MODIFIED MDI)
CAS:39310-05-9
Minumum % Wt:0.
Maxumum % Wt:30.
Other REC Limits:N/K
OSHA PEL:N/K
OSHA STEL:N/K
ACGIH TLV:N/K
ACGIH STEL:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL RAT): >5 G/KG.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:EYES:MAY CAUSE IRRIT. MAY CAUSE
SLIGHT TRANSIENT CORNEAL INJURY. SKIN: PROLONGED/REPEATED EXPOS
MAY CAUSE IRRIT/ALLERGIC SKIN & RESP REACTIONS. INHAL: VAPS &
AEROSOLS CAN IRRITATE EYES, NOSE & RE SP PASSAGES.SEV OVEREXP MAY
LEAD TO PULMONARY EDEMA. MDI CAN INDUCE RESP SENSIT W/ASTHMA-LIKE
SYMPTOMS INCLUDING CHRONIC COUGH, TIGHTNESS OF CHEST W/DIFFICULTY
IN BREATHING. SYMPTOMS MAY BE IMMEDI ATE/DELAYED SEVERAL HOURS
AFTER EXPOS. CHRONIC OVEREXPS MAY RESULT IN PERMANENT DECREASES IN
LUNG FUNCTION. INGEST: SINGLE DOSE TOXICITY IS EXTREMELY LOW & NOT
LIKELY TO CAUSE INJURY. (EFTS OF OVER EXP)
Explanation of Carcinogenicity:NO ASSOC HAS BEEN ESTABLISHED BETWEEN
INDUS EXPOS TO PETRO ASPHALT & CANCER IN HUMANS. IARC HAS
DETERMINED THERE IS LIMD EVIDENCE OF CARCINOGENICITY FOR UNDILUTED
STEAM-REFINED ASPHALTS IN EXPERIMENT AL ANIMALS & INSUFFICIENT
EVIDENCE OF CARCINOGENICITY FOR UNDILUTED STEAM-REFINED ASPHALTS IN
HUMANS. THESE ASPHALT SOURCES ARE NOT CONSTITUENTS OF CIM PREMIX.
Effects of Overexposure:HEALTH HAZARDS: ADDITIONAL HEALTH DATA: CIM
PREMIX IS USED WITH CIM ACTIVATOR TO FORM AN ELASTOMERIC COATING
FOR WATERPROOFING AND CORROSION PROTECTION. CONSULT THE MSDS FOR
CIM ACTIVATOR. AVOID INH ALATION OF THE ACTIVATED CIM MIXTURE
WHICH CONTAINS ISOCYANATES AND MAY RESULT IN SENSITIZATION AND
ALLERGIC RESPONSE IN SOME INDIVIDUALS.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH IMMED W/FRESH WATER FOR AT LST 15 MINS
CONTINUOUSLY WHILE HOLDING EYELIDS OPEN. IF IRRIT PERSISTS, SEE
MD. SKIN: WASH THORO W/SOAP & WATER. INHAL: MOVE PERSON TO FRESH
AIR & APPLY OXYGE N IF BREATHING IS DIFFICULT. IF BREATHING HAS
STOPPED, APPLY ARTIFICIAL RESPIRATION. CALL MD/TRANSPORT TO MEDICAL
FACILITY. NOTE TO MD: NO SPECIFIC ANTIDOTE. RESP SYMPTOMS MAY BE
DELAYED INCLUDING PULMONARY EDEMA. MAY CAUSE RESP SENSITIZATION.
INGEST: NO ADVERSE EFTS ANTICIPATED BY THIS ROUTE OF EXPOS
INCIDENTAL TO PROPER INDUSTRIAL HANDLING. CALL MD IMMED .
===================== Fire Fighting Measures =====================
Flash Point:=38.3C, 101.F
Autoignition Temp:>260.C, 500.F
Lower Limits:1%
Upper Limits:6%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM, WATER FOG,
HALON.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . SEE HAZARDOUS DECOMPOSITION PRODUCTS.READ THE ENTIRE
MSDS. NFPA HAZARD RATING: HEALTH: 1; FLAMMABILITY: 2;
REACTIVITY: 0; SPECIAL: 0.
Unusual Fire/Explosion Hazard:SOLVENTS CONTAINED IN PROD EVAPORATE &
FORM VAPOR (FUMES) WHICH CAN CATCH FIRE & BURN W/EXPLOSIVE
VIOLENCE. INVISIBLE VAP SPREADS EASILY & CAN BE SET ON FIRE BY
MANY SOURCES SUCH AS CIGARETTES, PILOT LIGHTS, WELDING EQUIP,
ELECTRICAL MOTORS & SWITCHES, & STATIC DISCHARGE. FIRE HAZARD IS
GREATER AS LIQUID TEMP RISES.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL OPEN FLAMES IN VICINITY OF SPILL
OR RELEASED VAPOR.CLEAN UP SMALL SPILLS USING APPROPRIATE
TECHNIQUES SUCH AS ABSORBENT MATERIALS OR PUMPING.WHERE FEASIBLE
AND APPROPRIATE, REMOVE CO NTAMINATED SOIL. FOLLOW PRESCRIBED
PROCEDURES FOR REPORTING AND RESPONDING TO LARGER RELEASES.
======================Handling and Storage ======================
Handling and Storage Precautions:READ & OBSERVE ALL PRECAUTIONS ON
PRODUCT LABEL. DO NOT USE OR STORE NEAR FLAME, SPARKS OR HOT
SURFACES. USE ONLY IN WELL-VENTILATED AREA. KEEP CONTAINER
CLOSED. DO NOT WELD, HEAT OR DRILL CONTAIN ER. REPLACE CAP OR
BUNG. EMPTIED CONTAINER STILL CONTAINS HAZARDOUS OR EXPLOSIVE
VAPOR OR LIQUID.
Other Precautions:CAUTION! DO NOT USE PRESSURE TO EMPTY DRUM OR
EXPLOSION MAY RESULT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE IN WELL-VENTILATED AREAS ONLY. WEAR A NIOSH
APPROVED TYPE C AIR SUPPLIED RESPIRATOR IF VENTILATION IS
INADEQUATE TO KEEP VAPORS AND MIST BELOW THE TLV.
Ventilation:USE IN WELL VENTILATED AREAS ONLY.
Other Protective Equipment:EMERGENCY EYEWASH AND DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA . SKIN CONTACT MAY BE MINIMIZED BY WEARING
PROTECTIVE CLOTHING.
Work Hygienic Practices:LAUNDER CLOTHES BEFORE REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:=154.4C, 310.F
Vapor Pres:3 MM HG @ 68F (20C)
Vapor Density:4.9(AIR=1)
Spec Gravity:0.9 @ 20/20C
Solubility in Water:SOLUBLE TO <300 PPM
Appearance and Odor:BLACK LIQUID WITH KEROSENE ODOR.
Percent Volatiles by Volume:<15
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MAY REACT WITH STRONG OXIDIZING MATERIALS.
Hazardous Decomposition Products:INCOMPLETE COMBUSTION CAN PRODUCE
CARBON MONOXIDE. NORMAL COMBUSTION FORMS CARBON DIOXIDE AND WATER
VAPOR AND MAY PRODUCE OXIDES OF NITROGEN.
=================== Toxicological Information===================
Toxicological Information:SKIN: LD50 (RABBIT): >2 G/KG.
===================== Ecological Information =====================
Ecological:THIS MATERIAL, IF NOT ACTIVATED WITH CIM ACTIVATOR, MAY BE
TOXIC TO AQUATIC ORGANISMS AND SHOULD BE KEPT OUT OF SEWAGE AND
DRAINAGE SYSTEMS AND ALL BODIES OF WATER.
==================== Disposal Considerations ====================
Waste Disposal Methods:PLACE CONTAMINATED MATERIALS IN DISPOSABLE
CONTAINERS AND DISPOSE OF IN A MANNER CONSISTENT WITH APPLICABLE
REGULATIONS. CONTACT LOCAL ENVIRONMENTAL OR HEALTH AUTHORITIES FOR
APPROVED DISPOSAL OF THI S MATERIAL. DISPOSE OF IN ACCORDANCE WITH
LOCAL, STATE, AND FEDERAL REGULATIONS .
=================== MSDS Transport Information ===================
Transport Information:DOT HAZARD: COATING SOLUTION, N.O.S., CLASS 3,
UN1139, PG III.
===================== Regulatory Information =====================
SARA Title III Information:THIS PRODUCT CONTAINS CERTAIN AROMATIC
SOLVENTS SUBJECT TO THE REPORTING REQUIREMENTS OF SECTION 313 OF
SARA TITLE III.
Federal Regulatory Information:THIS PRODUCT DOES NOT CONTAIN
CONSTITUENTS KNOWN TO BE A CARCINOGEN, MUTAGEN, TERATOGEN OR
REPRODUCTIVE TOXIN. SPILLS IN EXCESS OF 10,000 LBS MUST BE
REPORTED TO THE APPROPRIATE FEDERAL, STATE, AND L OCAL AUTHORITIES.
======================= Other Information =======================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:ZYGLO PENETRANT ZL-67
Preparer's Name:CHERI A. ZELENIK
CAGE:37676
CAGE:37676
============= Composition/Information on Ingredients =============
Ingred Name:SECONDARY ETHOXLYATED FATTY ALCOHOLS
CAS:68131-40-8
RTECS #:WZ5200000
Fraction by Wt: 40-70%
Other REC Limits:NONE RECOMMENDED
Ingred Name:METHYLOXIRANE POLYMER W/OXIRANE, MONO AND 37311-02-7,
52232-09-4
CAS:37251-67-5
Fraction by Wt: 10-30%
Other REC Limits:NONE RECOMMENDED
Ingred Name:NONYLPHENOL POLYETHOXATE
CAS:9016-45-9
RTECS #:MD0900000
Fraction by Wt: 7-13%
Other REC Limits:NONE RECOMMENDED
Ingred Name:PENTANEDIOIC ACID, DIMETHYL ESTER
CAS:1119-40-0
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:TLV: 5 MG/M3 FOR OILY MIST
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN CONTACT: CAN IRRITATE BY REMOVING
NATURAL SKIN OIL ON LONG OR REPEATED EXPOSURE. EYES: IRRITATING.
INHALATION: NOT SIGNIFICANT. WHEN HEATED OR SPRAYED, ZL-67 VAPORS
MAY CAUSE DIZZINESS AND NAUSEA . INGESTION: NOT SIGNIFICANT IN
SMALL (MOUTHFUL) AMOUNTS.
Explanation of Carcinogenicity:CONTAINS NO KNOWN OR SUSPECT CARCINOGENS
LISTED WITH OSHA, IARC, NTP OR ACGIH.
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NONE
======================= First Aid Measures =======================
First Aid:EYES: RINSE CAREFULLY UNDER UPPER AND LOWER EYELIDS USING
PLENTY OF WATER. SKIN: WASH OFF WITH SOAP AND WATER. USE SOOTHING
LOTION. INHALATION: REMOVE TO FRESH AIR IF DIZZY OR NAUSEATED.
INGESTION: DO NOT INDUCE VOMITING. ACCIDENTAL INGESTION OF A SMALL
MOUTHFUL IS NOT EXPECTED TO CAUSE SIGNIFICANT HARM. NOTE: IN ALL
SEVERE CASES, CONTACT PHYSICIAN IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>200F,>93C
Lower Limits:1%
Upper Limits:6%
Extinguishing Media:CARBON DIOXIDE, FOAM.
Fire Fighting Procedures:KEEP CONTAINERS COOL WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:MOP UP OR SWEEP UP WITH ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID BREATHING SPRAY MIST. AVOID
REPEATED OR PROLONGED SKIN CONTACT. AVOID EYE CONTACT. STORE AWAY
FROM HEAT SOURCE.
Other Precautions:EMERGENCY OVERVIEW: BLAND OILY LIQUID WHICH MAY
IRRITATE THE SKIN AND EYES. DIFFICULT TO IGNITE, BUT WILL BURN
VIGOROUSLY IF ENGULFED IN FIRE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESPIRATOR WITH FILTER IF SPRAYED IN ENCLOSED,
UNVENTILATED SPACE.
Ventilation:NONE, UNLESS APPLIED AS SPRAY. USE WHERE VENTILATION WILL
CARRY SPRAY MIST AWAY FROM OCCUPIED AREAS.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH HANDS AFTER EACH USE OF THIS PRODUCT
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:455F,235C
Vapor Pres:<0.10
Vapor Density:>1
Spec Gravity:0.99
pH:7
Evaporation Rate & Reference:NEGLIGIBLE
Solubility in Water:EMULSIFIES
Appearance and Odor:GREEN, OILY LIQUID, MILD ODOR.
Percent Volatiles by Volume:0%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:SOOT, OXIDES OF CARBON AND NITROGEN IF
HEATED TO COMBUSTION TEMPERATURE.
==================== Disposal Considerations ====================
Waste Disposal Methods:AS A NON-HAZARDOUS OILY WASTE, INCINERATE OR
SEND TO WASTE HANDLER WHO CAN BLEND IT INTO SECONDARY FUELS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:ADHESIVE: VPS TRAY
CAGE:GO270
CAGE:GO270
CAGE:33339
============= Composition/Information on Ingredients =============
Ingred Name:BENZIN, NAPHTHA, MINERAL SPIRITS, PETROLEUM NAPHTHA
CAS:8030-30-6
RTECS #:DE3030000
Fraction by Wt: >50%
Other REC Limits:STEL 400 PPM
OSHA PEL:100 PPM
ACGIH TLV:300 PPM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION. SKIN: IRRITATION &
POSSIBLE DERMATITIS. INHALATION: RESPIRATORY SYSTEM IRRITATION.
INGESTION: GASTROINTESTINAL IRRITATION; ASPIRATION INTO LUNGS MAY
CAUSE LUNG DAMAGE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES: REDNESS, SMARTING, TEARING, & SWELLING.
SKIN: DEFATTING, DRYNESS, CRACKING. INGESTION: NAUSEA, VOMITING,
DIARRHEA.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR AT LEAST 15 MINS. SKIN: WASH W/SOAP &
WATER. INHALATION: REMOVE TO FRESH AIR. INGESTION: DON'T INDUCE
VOMITING. DILUTE BY DRINKING SEVERAL GLASSES OF WATER. OBTAIN
MEDICAL ATTE NTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:85-90F
Extinguishing Media:DRY CHEMICAL, CO2
Fire Fighting Procedures:WEAR SCBA & FULL PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:DURING FIRE, IRRITATING/TOXIC GASES &
AEROSOLS MAY BE PRESENT.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE IGNITION SOURCES. COVER SPILL
W/ABSORBENT MATERIAL SUCH AS SAWDUST/SAND. SCOOP UP & PLACE IN AN
APPROPRIATE CONTAINER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AT AMBIENT TEMPERATURES OUT OF
DIRECT SUNLIGHT & HEAT. KEEP AWAY FROM FLAMES & SPARKS.
Other Precautions:DON'T STORE NEAR FOOD & BEVERAGES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR SELF-CONTAINED BREATHING APPARATUS WHEN
VAPORS EXCEED 100 PPM
Ventilation:LOCAL EXHAUST SUFFICIENT TO KEEP BELOW 100 PPM. MECHANICAL
(GENERAL): EXPLOSION PROOF MOTORS.
Work Hygienic Practices:HANDLE W/GOOD PERSONAL HYGIENE & SAFETY
PRACTICES.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:77-101F
Spec Gravity:<1
Solubility in Water:INSOLUBLE
Appearance and Odor:BLUE LIQUID W/SOLVENT ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:SPARKS & OPEN FLAMES
Hazardous Decomposition Products:SMOKE, VAPOR, CO2, CO
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE MATERIAL MAY BE INCINERATED IN ACCORDANCE
W/FEDERAL, STATE & LOCAL REGULATIONS. FLAMMABLE LIQUID. UN 1133.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:XO-RUST PLUS-VOC COMPLIANT, XOC-14
CAGE:3D277
CAGE:TRUTE
CAGE:3D277
============= Composition/Information on Ingredients =============
Ingred Name:TOLUENE (SARA 313) (CERCLA) VP: 22.0 @ 20C
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 20-30%
OSHA PEL:200 PPM
ACGIH TLV:50 PPM, S
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:XYLENE (SARA 313) (CERCLA) VP: 14.0 @ 20C
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 3-5%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/150STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:2-PENTANONE; (METHYL PROPYL KETONE) VP: 28.0 @ 20C
CAS:107-87-9
RTECS #:SA7875000
Fraction by Wt: 1-6%
OSHA PEL:200 PPM
ACGIH TLV:200 PPM/250STEL
Ingred Name:ACETIC ACID, BUTYL ESTER; (BUTYL ACETATE) (CERCLA) VP: 7.8
@ 20C
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: 1-5%
OSHA PEL:150 PPM
ACGIH TLV:150 PPM/200STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:HYDROCARBON PROPELLANT (PROPANE/ISOBUTANE);
(PROPANE/ISOBUTANE BLEND) VP: 80 PSI @ 20C
CAS:68476-86-8
Fraction by Wt: 25-30%
OSHA PEL:1000 PPM (MFR)
ACGIH TLV:1000 PPM (MFR)
Ingred Name:VOLATILE ORGANIC CONTENT: < 65%
RTECS #:9999999VO
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: SEVERE EYE IRRITATION, DRYING
OF SKIN. EXCESSIVE INHALATION CAUSES HEADACHE, DIZZINESS & NAUSEA.
CHRONIC: TOLUENE APPEARS ON THE NAVY OCCUPATIONAL CHEMICAL
REPRODUCTIVE HAZARDS LIST. SEEK CONSU LTATION FROM APPROPRIATE
HEALTH PROFESSIONALS CONCERNING LATEST HAZARD LIST INFO & SAFE
HANDLING & EXPOS INFO .
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE KNOWN TO MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. APPLY ARTIFICIAL RESPIRATION
IF NECESSARY. GET MEDICAL ATTENTION. SKIN: WASH WITH SOAP AND
WATER. EYES: FLUSH WITH LARGE AMOUNTS OF WATER FOR AT LEAST 15
MINUTES. GET MEDICAL ATTENTION. INGESTION: DO NOT INDUCE VOMITING.
KEEP PERSON WARM AND QUIET. GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:<20F,<-7C
Lower Limits:2.0%
Extinguishing Media:FOAM, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH APPRVD SCBA & FULL PROT EQUIP .
TREAT AS VOLAT LIQ FIRE. WATER SPRAY MAY BE INEFFECTIVE. IF WATER
IS USED, FOG NOZZ ARE PREF. (SUP DAT)
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. ISOLATE FROM HEAT, SPARKS AND OPEN FLAME.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES. CONTAIN SPILL,
ABSORB LIQUID WITH CLAY, SAND OR FLOOR ABSORBENT. PREVENT RUN-OFF
TO SEWERS, STREAMS AND OTHER BODIES OF WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLE AS AN EXTREMELY FLAMMABLE
MATERIAL. KEEP AWAY FROM HEAT, SPARKS AND OPEN FLAMES. FOR STORAGE
CONDITIONS SEE OSHA 1910.106.
Other Precautions:DO NOT EXPOSE OR STORE AT TEMPERATURES OVER 120F. DO
NOT TAKE INTERNALLY. AVOID PROLONGED CONTACT WITH SKIN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPRVED AIR SUPPLIED RESPIRATOR IF TLV
LIMITS ARE EXCEEDED. NIOSH APPROVED MECHANICAL FILTER TO REMOVE
SOLID AIRBORNE PARTICLES OF OVERSPRAY DURING SPRAY APPLICATION.
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL AND/OR LOCAL
EXHAUST) VENTILATION TO MAINTAIN EXPOSURE BELOW TLV.
Other Protective Equipment:ANSI APPROVED EMERGENCY EYEWASH & DELUGE
SHOWER . IMPERVIOUS CLOTHING & BOOTS ARE SUGGESTED TO PREVENT SKIN
CONT.
Work Hygienic Practices:WASH HANDS BEFORE EATING, SMOKING OR USING
BATHROOM. DO NOT REUSE CONTAMINATED CLOTHING.
Supplemental Safety and Health
FIRE FIGHT PROC: WATER MAY BE USED TO COOL SEALED CONTRS TO PVNT PRESS
BUILD UP & POSS EXPLO/AUTO IGNIT WHEN EXPOSED TO THE HEAT OF A
FIRE.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:0F,-18C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:ISOLATE FROM HEAT AND OPEN FLAME. DO NOT
EXPOSE TO TEMPERATURES ABOVE 120F.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTAMINATED ABSORBENT MAY BE DEPOSITED IN A
LANDFILL IN ACCORDANCE WITH LOCAL, STATE, AND FEDERAL REGULATIONS.
DISPOSE OF EMPTY CANS IN NON-INCINERATED TRASH ONLY.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:WATERPROOFING SEALER
CAGE:SEALK
CAGE:SEALK
============= Composition/Information on Ingredients =============
Ingred Name:NON-HAZARDOUS INGREDIENTS
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:VOLATILE ORGANIC COMPOUND: <6 G/L
RTECS #:9999999VO
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: POSSIBLE IRRITATION AND
DISCOMFORT. INHALATION: NONE EXPECTED, HOWEVER CERTAIN INDIVIDUALS
MAY BE SENSITIZED AND EXPERIENCE MINOR NAUSEA OR HEADACHE. SKIN:
NONE EXPECTED, HOWEVER, PROLONGED CON TACT MAY CAUSE IRRITATION.
EYES: CONTACT WITH EYES MAY CAUSE IRRITATION. INGESTION: MAY CAUSE
GASTRIC (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: DISTRESS, VOMITING AND DIARRHEA.
CHRONIC: NO KNOWN EFFECTS HAVE BEEN ESTABLISHED.
Medical Cond Aggravated by Exposure:PREEXISTING SKIN, EYE OR
RESPIRATORY DISORDERS MAY BECOME AGGRAVATED THROUGH PROLONGED
EXPOSURE.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. IF SYMPS PERSIT SEEK MED ATT.
SKIN: REMOVE CONTAMD CLTHG; WASH AFFECTED AREA W/SOAP & WATER.
LAUNDER CONTAM CLTHG BEFORE REUSE. IF IRRIT PERSISTS, SEEK MED
ATTN. EYES: FLUS H EYES W/CLEAR RUNNING WATER FOR AT LEAST 15 MIN
WHILE HOLDING EYELIDS OPEN. IF IRRIT PERSISTS, SEEK MED ATTN.
INGEST: GIVE TWO GLASSES OF WATER FOR DILUTION; INDUCE VOMITING BY
HAVING VICTIM (SUPDAT)
===================== Fire Fighting Measures =====================
Flash Point:>200F,>93C
Extinguishing Media:CARBON DIOXIDE, WATER FOG, DRY CHEMICAL, CHEMICAL
FOAM.
Fire Fighting Procedures:USE NIOSH APPRVD SCBA & FULL PROTECTIVE
EQUIPMENT . DO NOT USE SOLID STREAM OF WATER SINCE STREAM WILL
SCATTER & SPREAD FIRE. FINE WATER SPRAY (SUPDAT)
Unusual Fire/Explosion Hazard:CLOSED CNTNRS CAN EXPLODE DUE TO BUILDUP
OF PRESS WHEN EXPOSED TO EXTREME HEAT; DO NOT USE DIRECT STREAM OF
WATER ON POOL FIRES AS PROD MAY REIGNITE ON (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL SPILLS - WASH TO SANITARY SEWER WITH
PLENTY OF WATER. LARGE SPILLS - CONFINE SPILL, SOAK UP WITH
APPROVED ABSORBENT, SHOVEL PRODUCT INTO APPROVED CONTAINER FOR
DISPOSAL. WASH AREA WITH PLENTY OFWATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED WHEN NOT IN USE;
PROTECT CONTAINERS FROM ABUSE; PROTECT FROM EXTREME TEMPERATURES.
Other Precautions:KEEP THIS AND OTHER CHEMICALS OUT OF REACH OF
CHILDREN; MINIMIZE BODY CONTACT WITH THIS PRODUCT AS WELL AS ALL
CHEMICALS IN GENERAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED. USE NIOSH APPROVED RESPIRATOR
APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:MECHANICAL (GENERAL): RECOMMENDED.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:PRACTICE SAFE WORKPLACE HABITS. MINIMIZE BODY
CONTACT WITH THIS AS WELL AS ALL CHEMICALS IN GENERAL.
Supplemental Safety and Health
PH: 7.9-8.9. FIRE FIGHT PROC: CAN BE USED TO KEEP FIRE-EXPOSED
CONTAINERS COOL. EXPLO HAZ: WATER SURFACE. CAUTION-MATERIAL WILL
SUPPORT COMBUSTION. FIRST AID PROC: PLACE HIS FINGER DOWN HIS
THROAT; SE EK MED ATTN. NEVER GIVE ANYTHING BY MOUTH TO UNCON
PERSON.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:17 2 20C
Vapor Density:>1
Spec Gravity:1.023 (H*2O=1)
pH:SUPDAT
Evaporation Rate & Reference:<1 (H*2O=1)
Solubility in Water:EMULSIFIABLE
Appearance and Odor:CLEAR TO MILKY WHITE LIQUID; CHARACTERISTIC MILD
ODOR.
Percent Volatiles by Volume:90 WT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, STRONG ACIDS.
Stability Condition to Avoid:EXTREME TEMPERATURES.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY YIELD CARBON
MONOXIDE, CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF I/A/W LOC, STATE & FED REGS. PRODS
CLASSIFIED AS NON-HAZ MAY BECOME HAZ WASTE UPON CNTCT W/OTHER
PRODS. REFER TO "40 CFR PROT OF ENVIRONMENT PARTS 260-299" FOR
COMPLETE WASTE DISP REGS. CON SULT LOC/STATE/FED EPA BEFORE DISP OF
ANY CHEMS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:CENTARI 5000 ENAMEL, 525H
CAGE:B0589
CAGE:90227
CAGE:B0589
============= Composition/Information on Ingredients =============
Ingred Name:ACRYLIC RESIN
CAS:70942-12-0
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ACETIC ACID, BUTYL ESTER; (BUTYL ACETATE) (SARA III) VP:
8 @ 120C
CAS:123-86-4
RTECS #:AF7350000
OSHA PEL:150 PPM; 200 STEL
ACGIH TLV:150 PPM; 200 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:PIGMENT; (ISOINDOLINONE PIGMENT)
CAS:36888-99-0
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:2-HEPTANONE; (METHYL AMYL KETONE)VP: 2.2 @ 120C
CAS:110-43-0
RTECS #:MJ5075000
OSHA PEL:100 PPM
ACGIH TLV:50 PPM
Ingred Name:NICKEL OCTOATE
CAS:7580-31-6
Fraction by Wt: 2%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:QUINACRIDONE; (QUINACRIDONE PIGMENT)
CAS:1047-18-1
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:XYLENE (SARA III)VP: 25 @ 120C
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 9%
OSHA PEL:100 PPM; 150 STEL
ACGIH TLV:100 PPM; 150 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SUPDAT: KIDNEY WTS. RPTD EXPOS TO NICKEL OCTOATE MAY CAUSE
ALLERGIC SKIN RASH, ITCH, SWELL. HIGH CONC OF XYLENE (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8: HAVE CAUSED EMBRYOTOX EFTS IN LAB ANIMALS. RECURRENT
OVEREXP MAY RSLT IN LIVER & KIDNEY INJURY. CAN BE (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9: ABSORBED THROUGH THE SKIN IN HARMFUL AMOUNTS.
RTECS #:9999999ZZ
Ingred Name:SPILL PROC: ALLOW TO SIT 10 MIN, MINIMUM. TYPICAL DECONTAM
SOLNS ARE: 20% SURFACTANT (TERGITOL TMN 10) & 80% (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11: WATER OR 0-10% AMMONIA, 2-5% DETERGENT, BALANCE
WATER.
RTECS #:9999999ZZ
Ingred Name:RESP PROT: OR PRIOR REACTION TO ISOCYANATE SHOULD NOT
USE/BE EXPOSED TO THIS PROD. DO NOT PERMIT ANYONE W/OUT (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13: PROT IN PAINTING AREA. FOLLOW THE RESPIRATOR
MANUFACTURER'S DIRECTIONS FOR RESPIRATOR USE.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INGEST: GI DISTRESS. INHAL: MAY CAUSE
NOSE & THROAT IRRIT. RPTD & PRLNG OVEREXP TO SOLV MAY LEAD TO PERM
BRAIN & NERVOUS SYS DMG. EYE WATERING, HDCH, NAUS, DIZZ & LOSS OF
COORDINATION ARE SIGNS THAT S OLV LEVELS ARE TOO HIGH. EXPOS TO
ISOCYANATES MAY CAUSE RESP SENSIT. EFT MAY BE PERM & MAY BE DELAYED
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NICKEL CMPDS:IARC MONOGRAPHS ON
EVALUATION OF CARCIN RISK OF CHEMS TO MAN, VOL 49, PG 257, 1990:GRP
2B. NTP 6TH (SUPDAT)
Effects of Overexposure:HLTH HAZ: FOR SEVERAL HRS AFTER EXPOS. RPTD
OVEREXP TO ISOCYANATES MAY CAUSE DECR IN LUNG FUNC WHICH MAY BE
PERM. EYES: MAY CAUSE IRRIT/BURNING OF EYES. SKIN: RPTD/PRLNG LIQ
CNTCT MAY CAUSE IRRIT W/DI SCOMFORT & DERM. BUTYL ACETATE MAY CAUSE
ABNORM LIVER FUNC. TESTS FOR EMBRYOTOX ACTIVITY IN ANIMALS HAS BEEN
(SUPDAT)
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH BREATHING PROBLEMS
OR PRIOR REACTION TO ISOCYANATES MUST NOT BE EXPOSED TO VAPORS OR
SPRAY MIST OF THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:INGEST: CALL MD AND HAVE NAMES OF INGREDIENTS AVAILABLE.
INHAL: REMOVE TO FRESH AIR. IF BREATHING DIFFICULTY PERSISTS, OR
OCCURS LATER, CONSULT MD. EYES: IMMEDIATELY FLUSH WITH PLENTY OF
WATER FOR AT LEAST 15 MINUTES; CALL MD. SKIN: WASH WITH SOAP AND
WATER. IF IRRITATION OCCURS, CONTACT MD.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:100F,38C
Lower Limits:0.9%
Upper Limits:23%
Extinguishing Media:WATER SPRAY, FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . WATER FROM FOG NOZZLES MAY BE USED TO COOL CLOSED
CONTAINERS TO PREVENT PRESSURE BUILD UP.
Unusual Fire/Explosion Hazard:WHEN HEATED ABOVE FL PT, EMITS FLAMMABLE
VAPS WHICH, WHEN MIXED W/AIR, CAN BURN/BE EXPLO. FINE MISTS/SPRAYS
MAY BE FLAMMABLE AT TEMPERATURES BELOW THE FL PT.
================== Accidental Release Measures ==================
Spill Release Procedures:VENT AREA. DO NOT BREATHE VAPS/GET IN EYES/ON
SKIN. WEAR POS PRESS SUPPLIED AIR VAP/PARTICULATE RESP (NIOSH/MSHA
IGNIT. ABSORB W/INERT M ATL. POUR LIQ DECONTAM SOLN OVER SPILL &
(ING 11)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:OBSERVE LABEL PRECAUTIONS. KEEP AWAY
FROM HEAT, SPARKS & FLAME. CLOSE CNTNR AFTER EACH USE. GROUND
CNTNRS WHEN POURING. DO NOT STORE ABOVE 120F.
Other Precautions:DO NOT SAND, FLAME CUT, BRAZE OR WELD DRY COATING
WITHOUT A NIOSH/MSHA APPROVED RESPIRATOR OR APPROPRIATE
VENTILATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:DO NOT BREATHE VAPS/MIST. WEAR NIOSH/MSHA APPRVD
POS PRESS SUPPLIED AIR RESP (TC-19C) WHILE MIXING ACTIVATOR W/ANY
PAINT/CLEAR ENAMEL DURING APPLICATN & UNTIL ALL VAPS & SPRAY MISTS
ARE EXHAUSTED. PER S W/HISTORY OF LUNG/BRTHG PROBS (ING 13)
Ventilation:PROVIDE SUFFICIENT VENTILATION IN VOLUME & PATTERN TO KEEP
CONTAMINANTS BELOW APPLICABLE OSHA REQUIREMENTS.
Other Protective Equipment:COVERALLS.
Work Hygienic Practices:WASH THORO AFTER HANDLING AND BEFORE EATING OR
SMOKING. DO NOT STORE ABOVE 120F.
Supplemental Safety and Health
EXPLAN OF CARCIN: ANNUAL RPT ON CARCINS, 1991:ANTIC TO BE CARCIN.
HUMAN:LUNGS, NASAL CAVITIES. EFTS OF OVEREXP: INCONCLUSIVE. HAS
BEEN TOX TO FETUS IN LAB ANIMALS AT DOSES THAT ARE TOX TO MOTHER.
STUD IES ON LAB ANIMALS THAT INGESTED METHYL AMYL KETONE SHOWED
THAT VERY HIGH ORAL DOSES CAUSED INCR LIVER & (ING 8)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>135F,>57C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:0.79-1.89
Evaporation Rate & Reference:< ETHER
Solubility in Water:MISCIBLE
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:SUPDAT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE REASONABLY FORSEEABLE.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
SMOKE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT ALLOW MATERIAL TO CONTAMINATE GROUND
WATER SYSTEMS. INCINERATE ABSORBED MATERIAL IN ACCORDANCE WITH
FEDERAL, STATE AND LOCAL REQUIREMENTS. DO NOT INCINERATE IN CLOSED
CONTAINERS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:AEROSOL SPRAY PAINT TRUNK, 503
CAGE:07708
CAGE:07708
============= Composition/Information on Ingredients =============
Ingred Name:XYLENE. VP: 5.1 @ 20C.
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 0-5%
OSHA PEL:100 PPM;150 PPM STEL
ACGIH TLV:100 PPM;150 PPM STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:PROPANE, 2-METHYL-; (ISOBUTANE MIXTURE)
CAS:75-28-5
RTECS #:TZ4300000
Fraction by Wt: 20%
Ingred Name:NONHAZARDOUS INGREDIENTS
Fraction by Wt: 45-50%
Ingred Name:RESP PROT: APPROVED RESPIRATORY PROTECTION, OR LEAVE THE
AREA.
RTECS #:9999999ZZ
Ingred Name:EVAP RATE: LIQUID >1, PROPELLANTS <1. (BUTYL ACETATE=1),
LIQUID SLOWER THAN ETHER, PROPELLANT FASTER THAN ETHER.
RTECS #:9999999ZZ
Ingred Name:FL PT: 0F (LIQUID), -100F PROPELLANT.
RTECS #:9999999ZZ
Ingred Name:BENZIN; (V.M. AND P. NAPHTHA). VP: 15 @ 20C.
CAS:8030-30-6
RTECS #:DE3030000
Fraction by Wt: 30-35%
OSHA PEL:300 PPM (MFR)
ACGIH TLV:300 PPM (MFR)
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL: EXCESSIVE INHALATION OF
VAPS CAN CAUSE NASAL & RESP IRRIT, DIZZ, WEAKNESS, FATIGUE, NAUS,
HDCH, POSS UNCON & EVEN ASPHYXIATION. EYE: CAN CAUSE SEV IRRIT,
REDNESS, TEARING, BLURRED VISION . INGEST: CAN CAUSE GI IRRIT,
NAUS, VOMIT, DIARRHEA. SKIN: CAN CAUSE IRRIT FOR SOME PERSONS.
(EFTS OF OVEREXPOS)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:CHRONIC: REPORTS HAVE ASSOCD RPTD & PRLNGD
OCCUP OVEREXP TO SOLVS W/PERM BRAIN & NERVS SYS DAM. SEV OVEREXP IN
LAB ANIMALS HAS ALSO CAUSED LIVER ABNORMALITIES & DAM TO KIDNEYS,
LUNGS & SPLEEN, HEART & ADRENALS. INTENTIONAL MISUSE BY DELIB
CONCENTRATING & INHALING CONTENTS MAY BE HARMFUL OR FATAL.
Medical Cond Aggravated by Exposure:CAN CAUSE ALLERGIC RESPIRATORY
AND/OR SKIN REACTION.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. IF BRTHG IS DFCLT, ADMINISTER O*2.
IF BRTHG IS STOPPED, GIVE ARTF RESP & SEEK MD HELP. EYE:FLUSH
W/WATER FOR AT LEAST 15 MIN WHILE OCCASIONALLY HOLDING LIDS OPEN.
GET MD ATT N. INGEST:DO NOT INDUCE VOMIT (ASPIR OFMATL INTO LUNGS
CAN CAUSE CHEM PNEUMONITIS WHICH CAN BE FATAL. KEEP PERS WARM/QUIET
& GET MD ATTN/POISON CONTROL CENTER. SKIN:WASH W/SOAP & WATER/(SUPP
DATA)
===================== Fire Fighting Measures =====================
Flash Point:SEE ING 7
Lower Limits:1%
Extinguishing Media:ALCOHOL FOAM, CO*2, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. WATER SPRAY MAY BE INEFTIVE. WATER MAY BE USED TO COOL CLSD
CNTNRS TO PVNT PRESS BUILD-UP & (SUPP DATA)
Unusual Fire/Explosion Hazard:CLSD CNTNRS MAY EXPLODE &/AUTOIGNITE WHEN
EXPOS TO EXTREME HEAT. VAPS ARE HVR THAN AIR & MAY TRAVEL ALONG
GROUND/MAY BE MOVED BY VENT & IGNITED BY (SUPP DATA)
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES. VENTILATE
AREA. ABSORB LIQUID ON PAPER, VERMICULITE, FLOOR ABSORBENT, OR
OTHER ABSORBENT MATERIAL AND TRANSFER TO A CLOSED CONTAINER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE IN AREAS ABOVE 120F, IN
DIRECT SUNLIGHT, NEAR HEAT OR OPEN FLAMES. DO NOT PUNCTURE OR
INCINERATE.
Other Precautions:STORE LARGE QUANTITIES IN BUILDINGS PROTECTED FOR
STORAGE OF NFPA CLASS IC FLAMMABLE LIQUIDS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOR CASUAL/OCCASIONAL USE - TO AVOID BRTHG
VAPS/SPRAY MIST, OPEN WINDOWS & DOORS/USE OTHER MEANS TO ENSURE
FRESH AIR ENTRY DURING APPLICATN & DRYING.IF YOU EXPERIENCE EYE
WATERING/HDCHS/DIZZ, INCREASE FRESH AIR. WEAR NIOSH/MSHA (ING 5)
Ventilation:FOR REGULAR/CONTINUOUS USE - PROVIDE SUFFICIENT MECH (GEN)
&/LOC EXHAUST VENT TO MAINTAIN EXPOS BELOW TLV'S.
Other Protective Equipment:WHERE SPECIAL OR UNUSUAL CONDITIONS EXIST,
THE EXPERT ASSISTANCE OF AN INDUSTRIAL HYGIENIST SHOULD BE SOUGHT.
Work Hygienic Practices:WASH HANDS BEFORE EATING OR USING WASHROOM. AS
WITH ALL CHEMICALS, MINIMIZE PERSONAL CONTACT AND BREATHING OF
VAPORS.
Supplemental Safety and Health
FIRE FIGHT PROC:POSS AUTOIGNIT/EXPLO WHEN EXPOS TO EXTREME HEAT. IF
WATER IS USED, FOG NOZ ARE PREF. EXPLO HAZ:PILOT LIGHTS/OTHER
FLAMES/SPKS/HEATERS/SMOKING/ELEC MOTORS/OTHER IGNIT SOURCES AT
LOCATIO NS DISTANT FROM MATL HANDLING POINT. FIRST AID PROC:VARIOUS
HAND CLEANERS & WASH CLTHG BEFORE RE-USE.
================== Physical/Chemical Properties ==================
HCC:V3
Melt/Freeze Pt:M.P/F.P Text:1500F,816C
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Spec Gravity:<1 (H*2O=1)
Evaporation Rate & Reference:SEE ING 6
Solubility in Water:SLIGHT TO MODERATE
Appearance and Odor:TYPICAL SOLVENT PAINT
Percent Volatiles by Volume:85-90
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT, SPARKS & OPEN FLAME.
Hazardous Decomposition Products:MAY FORM TOXIC MATERIALS, CARBON
DIOXIDE/CARBON MONOXIDE, VARIOUS HYDROCARBONS, NITROGEN COMPOUNDS,
ETC. WHEN BURNED.
==================== Disposal Considerations ====================
Waste Disposal Methods:MATERIAL COLLECTED ON ABSORBENT MATERIAL MAY BE
DEPOSITED IN A POSTED TOXIC SUBSTANCE LANDFILL I/A/W LOCAL, STATE
AND FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:NICKEL PLASMA EMISSION STANDARD - 10,000 UG/ML
CAGE:0RP29
CAGE:0RP29
============= Composition/Information on Ingredients =============
Ingred Name:NICKEL (SARA 313) (CERCLA)
CAS:7440-02-0
RTECS #:QR5950000
Fraction by Wt: 1%
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3
Ingred Name:NITRIC ACID (SARA 302/313) (CERCLA)
CAS:7697-37-2
RTECS #:QU5775000
Fraction by Wt: 5%
OSHA PEL:2 PPM
ACGIH TLV:2 PPM;4 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: BALANCE
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL:HEADACHE, NAUSEA,
VOMITING, DIZZINESS, IRRITATION OF RESPIRATORY SYSTEM. SKIN/EYE
CONTACT:SEVERE IRRITATION. SKIN ABSORPTION:NONE IDENTIFIED.
INGEST:BURNS TO MOUTH, THROAT & STOMACH, KIDNE Y DISFUNCTION.
CHRONIC:NONE IDENTIFIED.TARGET ORGANS:NASAL CAVITIES, RESPIRATORY
SYSTEM, LUNGS, EYES, SKIN, TEETH.
Explanation of Carcinogenicity:NICKEL:IARC MONOGRAPHS ON EVAL OF CARCIN
RISK OF CHEMS TO MAN, VOL 49, PG 257, 1990:GRP 2B. NTP 7TH ANNUAL
RPT (SUPDAT)
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:DAMAGED SKIN, EYE DISORDERS,
CARDIOPULMONARY DISEASE.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD. IF SWALLOWED, DO NOT INDUCE VOMIT. IF
CONSCIOUS, GIVE WATER, MILK/MILK OF MAGNESIA. INHAL:REMOVE TO FRESH
AIR. IF NOT BRTHG, GIVE ARTF RESP. IF BRTHG IS DFCLT, GIVE OXYGEN.
SKIN:IMMEDFLUSH W/PLENTY OF WATER FOR AT LST 15 MINS WHILE
REMOVING CONTAM CLTHG & SHOES. WASH CLTHG BEFORE REUSE. EYES:IMMED
FLUSH W/PLENTY OF WATER FOR AT LST 15 MINS.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Extinguishing Media:USE EXTINGUISHING MEDIA APPROPRIATE FOR SURROUNDING
FIRE.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:REACTS W/MOST METALS TO PRODUCE HYDROGEN
GAS, WHICH CAN FORM AN EXPLOSIVE MIXTURE W/AIR.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT
CLOTHING. STOP LEAK IF YOU CAN DO SO W/OUT RISK. VENTILATE AREA.
NEUTRALIZE SPILL W/SODA ASH/LIME. WITH CLEAN SHOVEL, CAREFULLY
PLACE MATL INTO CLEAN, DRY CNTNR & COVER; REMOVE FROM AREA. FLUSH
SPILLW/WATER.
Neutralizing Agent:SODA ASH OR LIME.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED. STORE
IN SECURE POISON AREA. ISOLATE FROM INCOMPATIBLE MATERIALS.
Other Precautions:READ ALL PRECAUTIONARY INFORMATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:VENT HOOD.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . LAB COAT & APRON.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EXPLAN OF CARCIN:ON CARCINOGENS, 1994:ANTICIPATED TO BE CARCINOGEN.
HUMAN:LUNGS, NASAL CAVITIES. EYE PROT:& FULL LENGTH FACESHIELD .
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Melt/Freeze Pt:M.P/F.P Text:32.0F,0.0C
Spec Gravity:1 (H*2O=1)
Solubility in Water:COMPLETE (100%)
Appearance and Odor:COLORLESS LIQUID; ODORLESS.
Percent Volatiles by Volume:99
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG BASES, STRONG REDUCING AGENTS, ALKALIES, MOST COMMON METALS.
Stability Condition to Avoid:HEAT.
Hazardous Decomposition Products:OXIDES OF NITROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE I/A/W ALL APPLICABLE FEDERAL, STATE &
LOCAL ENVIRONMENTAL REGULATIONS. EPA HAZARDOUS WASTE NUMBER: D002
(CORROSIVE WASTE).
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:LEAD STANDARD 1000PPM, L-125
Preparer's Name:GENE C FEITH
CAGE:0H0Z7
CAGE:0H0Z7
============= Composition/Information on Ingredients =============
Ingred Name:LEAD (II) NITRATE (1:2); (LEAD NITRATE) (SARA 313) (MFR'S
CAS # 1009-97-48)
CAS:10099-74-8
RTECS #:OG2100000
Fraction by Wt: 0.2%
OSHA PEL:SEE 1910.1025
ACGIH TLV:0.15 MG(PB)/M3; 9495
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:NITRIC ACID (SARA 302/313) (CERCLA)
CAS:7697-37-2
RTECS #:QU5775000
Fraction by Wt: 0.7%
OSHA PEL:2 PPM
ACGIH TLV:2 PPM/4 STEL; 9495
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: BALANCE
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:LEAD NITRATE APPEARS ON NAVY LISTING
OF OCCUP CHEM REPRO HAZARDS. SEEK CONSULTATION FROM APPROP HLTH
PROFESSIONALS CONCERNING LATEST HAZARD LIST INFO & SAFE HNDLG &
EXPOS INFO . SUMMARY OF RISKS :CORR TO SKIN & EYES BECAUSE OF
NITRIC ACID CONTENT. INORGANIC LEAD CMPDS ARE PERIPHERAL
NEUROTOXINS (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:EXPOS MAY IRRITATE EYES, MUC MEMB, &
SKIN. POISONING AFFECTS G.I. TRACT, BLOOD & KIDNEYS. TARGET
ORGANS:KIDNEYS. CHRONIC:CHRONIC EYE CNTCT MAY CAUSE CONJ, SKIN
CNTCT MAY CAUSE DERM. INHAL OF LEAD NITRATE MAY CAUSE LEAD TO
BUILD UPIN THE BODY & POINT MAY BE REACHED WHERE SYMP & DISABILITY
MAY OCCUR. (SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH EYES W/H*2O FOR AT LEAST 15 MIN INCLUDING UNDER
EYELIDS. GET MED ATTN IF IRRIT/REDNESS DEVELOPS. SKIN:WASH W/SOAP &
H*2O. IF IRRIT DEVELOPS, GET MED ATTN. INHAL:REMOVE TO FRESH AIR.
RESTORE &/SUPPORT BRTHG. GET MED ATTN IMMED. INGEST:IF VICTIM IS
CONSCIOUS & NOT CONVULSING, GIVE LRG AMTS OF H*2O IMMED TO DILUTE
ACID. DO NOT INDUCE VOMIT. GIVE 1 OZ OF MILK OF MAGNESIA. GET MED
ATTN IMMED.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Extinguishing Media:USE THAT WHICH IS APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:COVER WITH SODA ASH. SCOOP UP AND PLACE IN
PROPER CONTAINER FOR DISPOSAL. CLOSE TIGHTLY AND LABEL CORROSIVE.
KEEP OUT OF SEWERS AND WATERWAYS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP IN A TIGHTLY CLOSED CONTAINER
AWAY FROM ANY INCOMPATABILITIES.
Other Precautions:CONTACT LENSES POSE A SPECIAL HAZARD; SOFT LENSES
ABSORB AND ALL LENSES CONCENTRATE IRRITANTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN . NOT EXPECTED TO BE REQUIRED UNLESS
MISTING IS PRESENT.
Ventilation:GENERAL IS ADEQUATE.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA .
Work Hygienic Practices:LAUNDER ANY CLOTHING BEFORE REUSE.
Supplemental Safety and Health
EFTS OF OVEREXP:SYMPTOMS INCLUDE FACIAL PALLOR, MILD JAUNDICE, ANEMAI,
INTENSE ABDOMINAL CRAMPING, NAUSEA, VOMITING, AND PERIPHERAL
NEUROPATHY. CHRONIC EXPOSURE GREATLY AFFECTS THE CENTRAL NERVOUS
SYS TEM.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:14=WATER
Vapor Density:0.7=WATER
Evaporation Rate & Reference:BUAC=1:GREATER THAN 1
Solubility in Water:COMPLETE
Appearance and Odor:A CLEAR COLORLESS LIQUID WITH NO ODOR.
Percent Volatiles by Volume:CA 99
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
REDUCING AGENTS, COMBUSTIBLE SUBSTANCES, ACTIVE METALS, POTASSIUM,
SODIUM, POTASSIUM ACETATE, AMMONIUM THIOCYANATE.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:WHEN HEATED TO DECOMPOSITION, IT EMITS
TOXIC FUMES OF PB AND NO*X.
==================== Disposal Considerations ====================
Waste Disposal Methods:FOLLOW ALL STATE, FEDERAL AND LOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:TRYPSIN 0.05% (W/V): EDTA 0.1% (W/V) (1X), 118-087-061
CAGE:0PXC7
CAGE:0PXC7
============= Composition/Information on Ingredients =============
Ingred Name:TRYPSIN. W/V: 0.5 G/L.
CAS:9002-07-7
RTECS #:YN5075000
Code:F
< Wt:.1
Other REC Limits:N/K
OSHA PEL:N/K
OSHA STEL:N/K
ACGIH TLV:N/K
ACGIH STEL:N/K
Ingred Name:DISODIUM EDTA DIHYDRATE; (DISODIUM EDTA). W/V: 1.0 G/L.
CAS:6381-92-6
RTECS #:AH4410000
= Wt:.1
Other REC Limits:N/K
OSHA PEL:N/K
OSHA STEL:N/K
ACGIH TLV:N/K
ACGIH STEL:N/K
Ingred Name:POTASSIUM CHLORIDE. W/V: 0.2 G/L.
CAS:7447-40-7
RTECS #:TS8050000
< Wt:.1
Other REC Limits:N/K
OSHA PEL:N/K
OSHA STEL:N/K
ACGIH TLV:N/K
ACGIH STEL:N/K
Ingred Name:POTASSIUM MONOPHOSPHATE; (POTASSIUM PHOSPHATE MONOBASIC).
W/V: 0.2 G/L.
CAS:7758-11-4
< Wt:.1
Other REC Limits:N/K
OSHA PEL:N/K
OSHA STEL:N/K
ACGIH TLV:N/K
ACGIH STEL:N/K
Ingred Name:SODIUM CHLORIDE. W/V: 8 G/L
CAS:7647-14-5
RTECS #:VZ4725000
= Wt:.8
Other REC Limits:N/K
OSHA PEL:N/K
OSHA STEL:N/K
ACGIH TLV:N/K
ACGIH STEL:N/K
Ingred Name:DISODIUM PHOSPHATE HEPTAHYDRATE; (SODIUM PHOSPHATE DIBASIC
7-HYDRATE). W/V: 2.2 G/L.
CAS:7782-85-6
RTECS #:WC4600000
= Wt:.2
Other REC Limits:N/K
OSHA PEL:N/K
OSHA STEL:N/K
ACGIH TLV:N/K
ACGIH STEL:N/K
Ingred Name:WATER. W/V: NOT APPLICABLE.
CAS:7732-18-5
RTECS #:ZC0110000
= Wt:98.9
Other REC Limits:N/K
OSHA PEL:N/K
OSHA STEL:N/K
ACGIH TLV:N/K
ACGIH STEL:N/K
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:THE TOXICOLOGICAL PROPERTIES OF THIS
PRODUCT HAVE NOT BEEN DETERMINED. THE SOLUTION MAY CAUSE ACUTE OR
CHRONIC IRRITATION OF SKIN, EYES AND MUCOUS MEMBRANES.
Effects of Overexposure:SEE HEALTH HAZARDS.
======================= First Aid Measures =======================
First Aid:INGESTION: REPEATEDLY RINSE MOUTH WITH WATER. DRINK LARGE
QUANTITIES OF WATER. GET MEDICAL ATTENTION IF IRRITATION PERSISTS.
SKIN: IMMEDIATELY WASH SKIN WITH SOAP AND FLUSH WITH LARGE AMOUNTS
OF WATER FOR AT LEAST 15 MINUTES. GET MEDICAL ATTENTION IF CONTACT
AREA REMAINS IRRITATED. EYES: IMMEDIATELY FLUSH EYES WITH LARGE
AMOUNTS OF WATER FOR AT LEAST 15 MINUTES. GET MEDICAL ATTENTION IF
EYES REMAI N IRRITATED. INHALATION: REMOVE TO FRESH AIR. SUPPORT
BREATHING (GIVE OXYGEN OR ARTIFICIAL RESPIRATION) . EMERGENCY
EXPOSURE INFORMATION: 1-800-424-8802 (NATIONAL RESPONSE CENTER).
===================== Fire Fighting Measures =====================
Extinguishing Media:USE EXTINGUISHING MEDIA APPROPRIATE TO SURROUNDING
FIRE CONDITIONS.
Fire Fighting Procedures:WEAR NIOSH APPROVED SELF-CONTAINED BREATHING
APPARATUS AND FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:MAY EMIT TOXIC FUMES OF CARBON MONOXIDE,
CARBON DIOXIDE, NITROGEN OXIDES, SODIUM AND PHOSPHOROUS OXIDES,
HYDROGEN CHLORIDE UNDER FIRE CONDITIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE CLOTHING AND SAFETY GLASSES
WHILE CLEANING UP THE SPILL. MINIMIZE SPREAD OF LIQUID USING
APPROPRIATE ABSORBENT MATERIAL. PLACE IN CLOSED CONTAINERS FOR
DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN TIGHTLY CLOSED CONTAINER AT
-10 TO -20C. MAY CAUSE EYE AND SKIN IRRITATION. DURING USE, AVOID
CONTACT WITH EYES, SKIN AND CLOTHING. WHEN NOT IN USE, KEEP IN
TIGHTLY CLOSED CONTAINER.
Other Precautions:THIS PRODUCT IS FOR RESEARCH USE ONLY. THIS PRODUCT
HAS NOT BEEN APPROVED FOR DIAGNOSTIC OR THERAPEUTIC USE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Other Protective Equipment:EYEWASH AND DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA . WEAR LAB COAT.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Appearance and Odor:CLEAR, PINK LIQUID; ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
=================== Toxicological Information===================
Toxicological Information:THE TOXICOLOGICAL PROPERTIES OF THIS PRODUCT
HAVE NOT BEEN DETERMINED.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE AND LOCAL ENVIRONMENTAL REGULATIONS.
======================= Other Information =======================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:NO. 2 DIESEL FUEL
Preparer's Name:M.N. MARTIN
CAGE:6G102
CAGE:6G102
============= Composition/Information on Ingredients =============
Ingred Name:PETROLEUM MID-DISTILLATE (DIESEL MARINE FUEL)
CAS:68476-34-6
Fraction by Wt: 100.0%
Other REC Limits:NONE SPECIFIED
OSHA PEL:5 MG/M3 AS OIL MIST
ACGIH TLV:5 MG/M3 AS OIL MIST
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION OF VAPOR MAY CAUSE
CENTRAL AND PERIPHERAL NERVOUS SYSTEM DEPRESSION AND RESPIRATORY
IRRITATION. CONTACT MAY CAUSE SKIN AND EYE IRRITATION. INGESTION
MAY CAUSE GI TRACT DISTURBANCES. CHRONIC: PROLONGED OR REPEATED
EXPOSUREMAY CAUSE DERMATITIS, PULMONARY EDEMA, PNEUMONITIS, AND
KIDNEY DAMAGE.
Explanation of Carcinogenicity:DATA PER MSDS ; DIESEL FUELS HAVE CAUSED
LIVER OR KIDNEY TUMORS.
Effects of Overexposure:INHALED: COUGHING, SHORTNESS OF BREATH,
DIZZINESS, WEAKNESS, NAUSEA, VOMITING, HEADACHE. EYES: REDNESS,
TEARING, DISCOMFORT. SKIN: REDNESS, DISCOMFORT. INGESTED: NAUSEA,
VOMITING, DIARRHEA, DIZZINESS, HEADACHE.
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF AILMENTS
OR WITH A PRE-EXISTING DISEASE INVOLVING THE EYES, SKIN, OR
RESPIRATORY TRACT MAY BE AT INCREASED RISK FROM EXPOSURE.
======================= First Aid Measures =======================
First Aid:INHALATION:REMOVE TO FRESH AIR. RESUSCITATE IF NOT BREATHING.
GET MEDICAL ATTENTION. EYES:IMMEDIATELY FLUSH WITH PLENTY OF WATER
FOR 15 MINUTES HOLDING EYELIDS OPEN. GET MEDICAL ATTENTION. SKIN:
REMOV E CONTAMINATED CLOTHING. WASH WITH SOAPAND WATER. IF
IRRITATION PERSISTS, GET MEDICAL ADVICE. INGESTION:DO NOT INDUCE
VOMITING. GIVE NOTHING BY MOUTH IF UNCONSCIOUS. GET IMMEDIATE
MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>100F,>38C
Lower Limits:0.7
Upper Limits:5.0
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED
CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION; REMOVE ALL
IGNITION SOURCES . CONTAIN FREE MATERIAL IF POSSIBLE;USE SUITABLE
INERT ABSORBENT MATERIAL AND RECOVER FOR PROPER DISPOSAL IN AN
APPROVED CONTAINER.
Neutralizing Agent:NOT APPLICABLE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY, WELL VENTILATED
AREA. KEEP CONTAINERS TIGHTLY CLOSED WHEN NOT IN USE. KEEP AWAY
FROM ALL IGNITION SOURCES. BOND AND GROUND CONTN
Other Precautions:DO NOT TAKE INTERNALLY. DO NOT BREATHE MIST. AVOID
PROLONGED OR REPEATED BREATHING OF VAPOR. AVOID CONTACT WITH EYES.
USE WITH ADEQUATE VENTILATION. WASH THOROUGHLY AFTER HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR AS REQUIRED
IF ABOVE PEL/TLV OR SCBA IN AN ENCLOSED AREA.
Ventilation:LOCAL/GENERAL TO MAINTAIN PEL/TLV.
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER,WORK
CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
AVOID PROLONGED OR REPEATED EXPOSURE. DO NOT GET ON SKIN OR IN EYES. DO
NOT BREATHE VAPORS OR MISTS.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:>325F,>163C
Vapor Pres:< 50 MM HG
Vapor Density:5-11
Spec Gravity:<1.0 (WATER=1)
Evaporation Rate & Reference:<1.0 (ETHER =1)
Solubility in Water:INSOLUBLE
Appearance and Odor:PALE YELLOW LIQUID WITH CHARACTERISTIC ODOR OF
KEROSENE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES AND OTHER SOURCES
OF IGNITION
Hazardous Decomposition Products:CARBON MONOXIDE AND OTHER PETROLEUM
DECOMPOSITION PRODUCTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONSULT LOCAL AUTHORITIES.DISPOSAL MUST BE MADE
IN ACCORDANCE WITH ALL APPLICABLE FEDERAL, STATE AND LOCAL LAWS AND
REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Preparer's Name:DOD HMIS/DGSC-SSH
CAGE:JO772
CAGE:14153
CAGE:JO772
============= Composition/Information on Ingredients =============
Ingred Name:ASBESTOS, CHRYSOTILE
CAS:12001-29-5
RTECS #:CI6478500
OSHA PEL:0.2 FIBERS/CC
ACGIH TLV:2 FIBERS/CC; A1;9192
Ingred Name:ASBESTOS & CLOROPRENE RUBBER COMPOSITION
RTECS #:9999999ZZ
Ingred Name:GENERIC "MSDS". SPECIFIC ASBESTOS TYPE NOT KNOWN. ONE
CITED IS ASSUMED. INFORMATION BASED ON SEGMENT "M" OF "DLSC TIR"
RTECS #:9999999ZZ
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: NO ACUTE EFFECTS ARE KNOWN;
CHRONIC: DUST FROM ABRASIVE ACTIONS(EG. CUTTING, MACHINING,
FILING, ETC.) MAYCONTAIN ASBESTOS FIBERS. CHRONIC OVEREXPOSURE
TO AIRBORNE FIBERS MAY LEAD TO ASBESTOSIS & MESOTHELIOMA.
SMOKINGCOMBINED W/FIBER INHALATION GREATLY INCREASES LUNG
CANCER RISK!
Explanation of Carcinogenicity:OVEREXPOSURE TO AIRBORNE CONCENTRATIONS
OF ASBESTOS MAY LEAD TO ASBESTOSIS AND MESOTHELIOMA.
Effects of Overexposure:INHAL: INHALATION OF AIRBORNE DUST CONTAINING
ASBESTOS FIBERS ON REPEATED EXPOSURE MAY CAUSE OR CAN LEAD TO
ASBESTOSIS/ MESOTHELIOMA; SKIN: N/K; EYE: POTENTIAL IRRITATION
FROM AIRBORNE DUST; INGEST: N/K.
Medical Cond Aggravated by Exposure:RESPIRATORY DEFICIENCIES DUE TO
REPEATED INHALATION OF AIRBORNE FIBERS.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. OBTAIN MEDICAL ADVICE; SKIN:
WASH EXPOSED AREA WITH SOAP & WATER; EYE: FLOOD W/ WATER. IF
IRRITATION OCCURS, GET MEDICAL ATTN; INGEST: CONSULT A
PHYSICIAN; OTHER: CHANGE CLOTHING AS REQUIRED TO AVOIDCARRYING
DUST PARTICLES INTO OTHER AREAS
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:MATERIAL IS NOT FLAMMABLE ; USE MEDIA APPROPRIATE
FOR SURROUNDING FIRE.
Fire Fighting Procedures:COMBUSTION PRODUCTS OF THIS MATERIAL MAY BE
TOXIC. USE A SELF-CONTAINED BREATHING APPARATUS WHEN FIGHTING FIRES
INVOLVING CHEMICAL PRODUCTS.
Unusual Fire/Explosion Hazard:NONE KNOWN
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION. VACUUM OR WET
CLEAN IF DUST IS INVOLVED. ANY VACUUM SYSTEM SHOULD BE EQUIPPED W/
AN OUTLET "HEPA" FILTER TO PREVENT REINTRODUCING ASBESTOS FIBERS TO
THE ATMOSPHERE.
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLE IN A MATTER TO MINIMIZE
FORMATION OR RETENTION OF AIRBORNE DUST. USE PROPER PERSONAL
PROTECTION FOR TASK AT HAND. CHECK W/YOUR SAFETY OFFICE!!!
Other Precautions:AS MANUFACTURED, LOCKED-IN ASBESTOS DOES NOT PRESENT
A HAZARD. ONLY WHEN THE ITEM IS SUBJECTED TO ABRASIVE ACTIONS &
DUST IS GENERATED, THEN ASBESTOS FIBERS MAY BE RELEASED & BECOME
AIRBORNE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF EXPOSURES EXCEED ESTABLISHED LIMITS, A
NIOSH/MSHA APPROVED RESPIRATOR FOR ASBESTOS SHOULD BE USED.
CONSULT YOUR SAFETY OFFICE/IH PERSONNEL FOR GUIDANCE FOR THE TASK
AT HAND.
Ventilation:LOCAL EXHAUST IS RECOMMENDED IN SITUATIONS WHERE DUST IS
GENERATED BY ABRASIVE ACTIONS, ABRASION OR OTHER MEANS.
Other Protective Equipment:AS REQUIRED FOR TASK AT HAND, AND THE
GUIDANCE SET FORTH BY YOUR SAFETY OFFICE OR IH PERSONNEL
Work Hygienic Practices:DONOT INHALE DUST CREATED BY ABRADING ACTIONS.
USE FULL PROTECTION AGAINST AIRBORNE FIBERS. AVOID AIRBORNE DUST
CREATION
Supplemental Safety and Health
GENERIC "MSDS" CREATED FOR "NSN" IDENTIFIED BY "DISC" AS CONTAINING
ASBESTOS.WHEN A MANUFACTURER'S SPECIFIC "MSDS" IS PROVIDED FOR
MATERIAL PROCURED UNDER THIS NSN, THIS GENERIC "MSDS" WILL BE
REMOVED.
================== Physical/Chemical Properties ==================
HCC:T6
Evaporation Rate & Reference:NONE
Solubility in Water:NOT SOLUBLE
Appearance and Odor:MANUFACTURED COMMODITY DESCRIBED BY LOGISTICS:
"ITEM-NAME"
Percent Volatiles by Volume:NONE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:NONE KNOWN
==================== Disposal Considerations ====================
Waste Disposal Methods:DUST SHOULD BE HANDLED AS A HAZARDOUS AIR
POLLUTANT I/A/W 40CFR61 SUBPART "M" PERTAINING TO ASBESTOS. USE
LANDFILLS APPROVED FOR ASBESTOS DISPOSAL. NOTE IF ITEM UNDER
CONSIDERATION FOR DISPOSAL IS "FRIABLE OR NON-FRIABLE".
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:MACHINERY GRADE RUST STOP ENAMEL, 220A117
CAGE:ACEHA
CAGE:ACEHA
============= Composition/Information on Ingredients =============
Ingred Name:2-NAPHTHOL, 1-((2,4 DINITROPHENYL)AZO)-; (DINITRANILINE
ORANGE)
CAS:3468-63-1
RTECS #:QL3854000
Fraction by Wt: 8.2%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:MINERAL SPIRITS.
CAS:64742-88-7
Fraction by Wt: 25.8%
OSHA PEL:100 PPM (MFR)
ACGIH TLV:100 PPM (MFR)
Ingred Name:2-NAPHTHALENOL, 1-((4-METHYL-2-NITROPHENYL)AZO)-; (AZO RED
PIGMENT)
CAS:2425-85-6
RTECS #:QK4247000
Fraction by Wt: 7.6%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 24.1%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:IRON HYDROXIDE OXIDE; (YELLOW IRON OXIDE)
CAS:20344-49-4
Fraction by Wt: 7.7%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:IRRITATION OF EYES, SKIN AND
RESPIRATORY SYSTEM MAY OCCUR ON OVEREXPOSURE. MAY ALSO CAUSE
NERVOUS SYSTEM DEPRESSION. SIGNS & SYMPS OF EXPOS:HEADACHE,
DIZZINESS, NAUSEA & LOSS OF COORDINATION ARE INDICATIONS OF
EXCESSIVE EXPOSURE TO VAPORS OR SPRAY MISTS. CHRONIC:REPORTS HAVE
ASSOCIATED REPEATED (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:AND PROLONGED OCCUPATIONAL
OVEREXPOSURE TO SOLVENTS WITH PERMANENT BRAIN AND NERVOUS SYSTEM
DAMAGE.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD IMMEDIATELY . INHAL:REMOVE FROM EXPOSURE -
RESTORE BREATHING - KEEP WARM AND QUIET. SKIN:WASH AFFECTED AREA
THOROUGHLY WITH SOAP & WATER. EYES:FLUSH WITH LARGE AMOUNTS OF
WATER FO R @ LEAST 15 MINUTES. GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:105F,41C
Lower Limits:0.9%
Extinguishing Media:FOR DRY SOLIDS, USE WATER, FOAM, CO*2, DRY
CHEMICALS.
Fire Fighting Procedures:NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP .
WATER MAY BE USED TO COOL USED CNTNRS TO PVNT PRESS BUILD-UP & POSS
AUTO IGNIT/EXPLO WHEN EXPOS TO (SUPDAT)
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM
HEAT, ELEC EQUIP, SPK & OPEN FLAME. HEAT MAY CAUSE PRESS BUILD-UP
IN CLSD CNTNRS. WATER MAY BE USED TO COOL.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:CONTENTS ARE COMBUSTIBLE. KEEP AWAY
FROM HEAT AND OPEN FLAME. USE APPRVD BONDING AND GROUNDING
PROCEDURES.
Other Precautions:TRANSFER ONLY TO APPRVD, PROPERLY MARKED CONTAINERS.
KEEP OUT OF REACH OF CHILDREN. INTENTIONAL MISUSE BY DELIBERATELY
INHALING THE CONTENTS CAN BE HARMFUL OR FATAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED PROPERLY FITTED ORGANIC
VAPOR/PARTICULATE RESPIRAOTR.
Ventilation:LOCAL EXHAUST:PREFERABLE.
Other Protective Equipment:ANSI APPRVD EMERGENCY EYE WASH & DELUGE
SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EVAP RATE:SLOWER/ETHER (BUTYL ACETATE =1). FIRE FIGHT PROC:EXTREME
HEAT.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:308F,153C
Vapor Density:HVR/AIR
Spec Gravity:1.12 (H*2O=1)
Evaporation Rate & Reference:SUPP DATA
Appearance and Odor:COLORED PIGMENTED LIQUID WITH SOLVENT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:BY FIRE-CARBON DIOXIDE, CARBON
MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE IN APPROVED FACILITY. DO NOT
INCINERATE CLOSED CONTAINERS. DISPOSE OF IN ACCORDANCE WITH
FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:TRICINE GELS:6626;6675;66752
CAGE:1ENU5
CAGE:1ENU5
============= Composition/Information on Ingredients =============
Ingred Name:ACRYLAMIDE. LD50:(ORAL,RAT) 295 MG/KG.
CAS:79-06-1
RTECS #:AS3325000
Fraction by Wt: </= 0.2%
Other REC Limits:PEL:0.03 MG/M3,S (M)
OSHA PEL:0.3 MG/M3
ACGIH TLV:0.03 MG/M3
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:SODIUM AZIDE
CAS:26628-22-8
RTECS #:VY8050000
= Wt:.02
ACGIH STEL:C0.29 MG/M3
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENTS & TOXICOLOGICAL INFO.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: MAY CAUSE DAMAGE TO THE CENTRAL
NERVOUS SYSTEM. CHRONIC: MAY CAUSE NEUROPATHY SUCH AS INCREASED
SWEATING, TINGLING AND WEAKNESS IN THE HANDS AND FEET. UNSTEADY
GAIT AND DECREASED REFLEXES MAY A LSO BE OBSERVED. EITHER ACUTE OR
CHRONIC EXPOSURE MAY LEAD TO WEAK OR ABSENT REFLEXES. AN EARLY SIGN
OF OVEREXPOSURE IS PEELING OF SKIN OF FINGERTIPS.
Explanation of Carcinogenicity:ACRYLAMIDE: IARC MONOGRAPHS, VOL 60, PG
389, 1994:GROUP 2A. NTP 8TH ANNUAL REPORT ON CARCINOGENS, 1998:
REASONABLY ANTICIPATED TO BE HUMAN CARCINOGEN. ANIMAL: CNS TOXIN,
NEOPLASMS.
Effects of Overexposure:INHALATION: AIRBORNE ACRYLAMIDE IS READILY
ABSORBED THROUGH THE LUNG AND OVEREXPOSURE WILL PRODUCE SIGNS OF
NEUROPATHY. CONTACT WITH EYES: SODIUM AZIDE: MAY CAUSE IRRITATION.
ACRYLAMIDE: MAY CAUSE CON JUNCTIVAL IRRITATION. ABSORBED THROUGH
SKIN: ACRYLAMIDE: READILY ABSORBED THROUGH SKIN. MAY CAUSE DAMAGE
TO THE CENTRAL NERVOUS SYSTEM. INGESTION: NEUROTOXICITY FROM A
SINGLE INGESTION CAN RESULT BUT IS MORE LIKELY TO OCCUR AFTER
REPEATED INGESTION OF SMALL AMOUNTS OVER A PERIOD OF SEVERAL DAYS
OR WEEKS.
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH WITH LARGE AMOUNTS OF WATER FOR AT
LEAST 15 MINUTES, LIFTING UPPER & LOWER LIDS OCCASIONALLY. GET
IMMEDIATE MED ATTN. SKIN: IMMEDIATELY REMOVE ANY CONTAMINATED
CLOTHING WITHOUT DELAY. DO NOT RE-USE CONTAMINATED CLOTHING
WITHOUT RE-LAUNDERING. WASH SKIN WITH SOAP OR MILD DETERGENT &
WATER FOR AT LEAST 15 MINUTES. GET MED ATTN IF IRRIT DEVELOPS OR
PERSISTS. INHAL: REMOVE TO F RESH AIR. IF NOT BREATHING GIVE CPR.
CONSULT MED PERSONNEL. IF BREATHING IS DIFFICULT, GIVE OXYGEN.
INGEST: GIVE TWO GLASSES OF WATER & THEN INDUCE VOMITING. NEVER
GIVE ANYTHING BY MOUTH TO AN UNCONSC IOUS PERSON. GET MED ATTN
IMMEDIATELY.
===================== Fire Fighting Measures =====================
Extinguishing Media:NOT COMBUSTIBLE. USE WHATEVER IS NEEDED TO PUT OUT
SURROUNDING FIRE.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NOT APPLICABLE.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA OF SPILL ABSORB LIQUID SPILLS
WITH A DRY INERT ABSORBENT MATERIAL. DO NOT PERMIT LIQUID SPILLS TO
DRY. CONTAINERIZE ABSORBED MATERIAL FOR DISPOSAL IN AN APPROVED
WASTE FACILITY.
======================Handling and Storage ======================
Handling and Storage Precautions:RECOMMENDED STORAGE CONDITIONS:
REFRIGERATED, IN THE DARK. STORAGE TEMPERATURE MAXIMUM: 60F/15C.
KEEP CONTAINER TIGHTLY SEALED TO PROTECT QUALITY. STORE AT 4-10C.
KEEP AWAY FROM HEAT SOURCES.
Other Precautions:PROTECTIVE MEASURES DURING MAINTENANCE OF
AND NIOSH APPROVED RESPIRATORY EQUIPMENT MUST BE WORN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN . NOT REQUIRED WHEN SUFFICIENT VENTILATION IS
PROVIDED.
Ventilation:GOOD ENCLOSURE AND LOCAL VENTILATION SHOULD BE PROVIDED.
Other Protective Equipment:EYE WASH & DELUGE SHOWER MEETING ANSI DESIGN
CRITERIA . WEAR LAB COAT OR APRON.
INSIDE. WASH HANDS AFTER USING & BEFORE EATING. DO NOT EAT, SMOKE
OR DRINK IN WORK AREA.
Supplemental Safety and Health
PHYSICAL/CHEMICAL CHARACTS: SOLUBILITY IN WATER: UNPOLYMERIZED MATERIAL
SOLUBLE IN ANY PROPORTIONS.
================== Physical/Chemical Properties ==================
Boiling Pt:=100.C, 212.F
Melt/Freeze Pt:=0.C, 32.F
Vapor Pres:SAME AS WATER
Spec Gravity:1.0
Solubility in Water:(SUPP DATA)
Appearance and Odor:CLEAR GEL AND PACKAGING BUFFER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AND REDUCING AGENTS, BRASS, ALUMINUM, COPPER, IRON AND
PEROXIDES.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY PRODUCE
CARBON MONOXIDE, CARBON DIOXIDE, AMMONIA AND/OR OXIDES OF NITROGEN.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
=================== Toxicological Information===================
Toxicological Information:ACRYLAMIDE (100%) = LD50:(DERMAL,RABBIT) 252
MG/KG. SODIUM AZIDE = LD50:(ORAL,RAT) 27 MG/KG;
LD50:(DERMAL,RABBIT) 20 MG/KG.
===================== Ecological Information =====================
Ecological:AQUATIC STUDIES: 96 HOUR STATIC ACUTE LC50-RAINBOW TROUT=130
MG/L. 96 HR NO OBSERVED EFFECT CONC 32 MG/L IS BASED ON NO
MORTALITY OR ABNORMAL EFFECTS. TOXICITY RATING: SLIGHTLY TOXIC. 96
HOUR STATIC A CUTE LC50 TO FATHEAD MINNOW=75 MG/L. 96 HR NO
OBSERVED EFFECT CONC IS 5.6 MG/L BASED ON NO MORTALITY OR ABNORMAL
EFFECTS. TOXICITY RATING: MODERATELY TOXIC. 48 HR STATIC ACUTE
LC50-DAPHNIA MAGNA=190 M G/L. 48 HR NO OBSERVED EFFECT CONC IS 100
MG/L BASED ON NO MORTALITY OR ABNORMAL EFFECTS. TOXICITY RATING:
SLIGHTLY TOXIC. 96 HR STATIC ACUTE LC50 TO SHEEPSHEAD MINNOW=454
MG/L. 96 HR NO OBSERVED EFFE CT CONC IS 250 MG/L BASED (TRANSPORT)
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE DONE I/A/W ALL APPLICABLE
FEDERAL, STATE & LOCAL REGULATIONS ON SPILL REPORTING, WASTE
HANDLING & WASTE DISPOSAL.
=================== MSDS Transport Information ===================
Transport Information:PROPER SHIPPING NAME/HAZARD CODE-ALKYLAMINES,
N.O.S. (DEPENDENT UPON MODE, PACKAGE) 8 (3), UN 2734, PGII.
CONTAINS: CYCLOHEXYLAMINE, DIETHYLAMINOETHANOL, MORPHOLINE.
ECOLOGICAL INFO (CONT): ON NO MO RTALITY OR ABNORMAL EFFECTS.
TOXICITY RATING: SLIGHTLY TOXIC. 96 HR STATIC ACUTE LC50 TO MYSID
SHRIMP=131 MG/L 96 HR NO OBSERVED EFFECT CONC IS 40 MG/L BASED ON
NO MORTALITY OR ABNORMAL EFFECTS. TOXIC ITY RATING: SLIGHTLY TOXIC.
IF RELEASED INTO ENVIRONMENT, SEE CERCLA, SECTION 14. TOXICOLOGY
INFO (CONT): EXTREMELY IRRIT (CORR). SKIN SENSITIZATION:
CYCLOHEXYLAMINE CAN CAUSE SENSITIZATION (CONTACT NEHC FOR
ADDITIONAL INFORMATION)
===================== Regulatory Information =====================
SARA Title III Information:THIS PRODUCT CONTAINS THE FOLLOWING TOXIC
CHEMICAL SUBJECT TO THE REPORTING REQUIREMENTS OF SECTION 313 OF
THE EMERGENCY PLANNING AND COMMUNITY RIGHT-TO-KNOW ACT OF 1986 AND
OF 40 CFR 372: ACRYLAMIDE (CAS # 79-06-1) </= 0.2% AND SODIUM
AZIDE (CAS # 26628-22-8) 0.02%.
State Regulatory Information:
======================= Other Information =======================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:COLOR SHADES, 6805 BARLEY WHITE
CAGE:72818
CAGE:72818
CAGE:01PD6
============= Composition/Information on Ingredients =============
Ingred Name:CERAMIC BONDED ALUMINA
CAS:66402-68-4
Fraction by Wt: 10-20%
OSHA PEL:10 MG/M3 (MFR)
ACGIH TLV:5 MG/M3 (MFR)
Ingred Name:TALC (POWDER), CONTAINING NO ASBESTOS FILBERS
CAS:14807-96-6
RTECS #:WW2710000
Fraction by Wt: 5-10%
OSHA PEL:0.2 FIBERS/CC
ACGIH TLV:0.2 FIBER/CC, A1
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 1-15%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:VINYL ACRYLIC COPOLYMER
CAS:25586-24-7
Fraction by Wt: 5-10%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 60-70%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:VOLATILE ORGANIC COMPOUND:22.21
RTECS #:9999999VO
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPDAT:RATS (LUNG & ADRENAL TUMORS) & SOME EVID OF CARCIN
IN MALE RATS (ADRENAL TUMORS). NO EVID OF CARCIN WAS (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7:DEMONSTRATED IN MALE & FEMALE MICE EXPOS UNDER SAME
CNDNTNS. MICROSCOPIC EXAMINATION OF LUNGS OF RATS & (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8:MICE EXPOSED TO TALC REVEALED ADDNL EXPOS RELATED
EFTS PRIMARILY ASSOC W/INFLAMMATORY REPONSE.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC:IMMED W/LG AMTS OF WATER, ESPECIALLY UNDER
LIDS FOR AT LST 15 MINS. IF IRRIT/OTHER EFTS PERSIST, (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10:OBTAIN MED TREATMENT. INGEST:OBTAIN MEDICAL
TREATMENT IMMEDIATELY.
RTECS #:9999999ZZ
Ingred Name:SPILL PROC:LEAK IF SAFE TO TO DO. DIKE & CONTAIN SPILL.
PUMP TO STOR/SALV VESSELS. USE ABSORB TO PICK UP EXCESS (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12:RESIDUE. KEEP SALVAGEABLE MATL & RINSE WATER OUT OF
SEWERS & WATER COURSES. SM SPILLS:USE ABSORB TO PICK (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13:UP RESIDUE AND DISPOSE OF PROPERLY.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC:AVOIDED, USE APPROP NIOSH APPRVD RESP PROT AS
DIRECTED UNDER SPEC PROT INFO. EMPTY CNTNRS MAY CONTAIN(ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15:HAZ RESIDUES. GROUND EQUIP WHEN TRANSFERRING TO PVNT
ACCUM OF STATIC CHARGE.
RTECS #:9999999ZZ
Ingred Name:EYE PROT:& FULL LENGTH FACESHIELD .
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL:IRRIT OF RESP TRACT,
LUNGS. PRLNGD INHAL MAY LEAD TO DROW, DIZZ AND/OR LT HEAD,
UNCOORDINATION, COUGH, SNEEZING, RESP PROBLEMS, ANESTH EFT/NARCOS,
LOSS OF CONSCIOUSNESS. SKIN:IRRIT. PRLNGD /RPTD CONT CAN CAUSE
DERM, BLISTERING, SEV SKIN IRRIT. POSSIBLE SENSIT TO SKIN.
EYE:IRRIT. PRLNGD/RPTD (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:CONT CAN CAUSE TEARING, REDNESS, SEV
IRRIT, CORNEAL INJURY. INGEST:MAY CAUSE DROW, DIZZ AND/OR LT HEAD,
HDCH, NAUS, VOMIT, DIARR, GI DISTURB, CNS DEPRESS, ANESTH
EFT/NARCOS, KIDNEY DMG, LOSS OF CONSCIOUSNESS. INHAL OF
NON-ASBESTIFORM COSMETIC GRADE TALC FOR 2 YRS @ 6 & 18 MG/M3 PRDCED
CLEAR EVID OF (SUPDAT)
Medical Cond Aggravated by Exposure:EYE, SKIN, RESPIRATORY DISORDERS.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. RESTORE & SUPPORT CONTINUED BRTHG.
GET EMER MED ATTN. HAVE TRAINED PERSON GIVE OXYG IF NEC. GET MED
HELP FOR ANY BRTHG DFCLTY. REMOVE TO FRESH AIR IF INHAL CAUSES EYE
WATERI NG, HDCH, DIZZ/OTHER DISCOMFORT. SKIN:FLUSH W/WATER. THEN
WASH THOROUGHLY W/SOAP & WATER. REMOVE CONTAMD CLTHG. WASH CONTAMD
CLTHG BEFORE RE-USE. IF IRRIT OCCURS, CONSULT PHYS. EYE:FLUSH (ING
10)
===================== Fire Fighting Measures =====================
Flash Point:>200F,>93C
Extinguishing Media:DRY CHEMICAL OR FOAM WATER FOG. CARBON DIOXIDE.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . WATER MAY BE USED TO COOL & PROTECT EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:CLSD CNTNRS MAY EXPLODE WHEN EXPOS TO
EXTREME HEAT/FIRE. VAPS ARE HVR/AIR & MAY TRAVEL LONG DIST TO
SOURCE OF IGNIT & FLASH BACK. VAPS CAN FORM EXPLO (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:COMPLY W/ALL APPLIC HLTH & ENVIR REGS. ELIM
ALL SOURCES OF IGNIT. VENTIALTE AREA. EVAC ALL UNNEC PERS. PLACE
COLLECTED MATL IN PROPER CNTNR. VACUUM CLEAN SPILLAGE. COMPLETE
PERSONAL PROT EQUIP MUST BE USED DURING CLEANUP. LG SPILLS-SHUT
OFF (ING 12)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE <100F. KEEP AWAY FROM HEAT, SPKS
& OPEN FLAME. KEEP FROM FREEZING. USE ONLY W/ADEQ VENT. DO NOT TAKE
INTERNALLY. KEEP OUT OF REACH OF CHILDREN.
Other Precautions:AVOID CONT W/SKIN & EYES, & BRTHG OF VAPS. KEEP
CNTNRS TIGHTLY CLSD & UPRIGHT WHEN NOT IN USE. AVOID CNDTNS WHICH
RSLT IN FORMATION OF INHALABLE PARTICLES SUCH AS
SPRAYING/ABRADING(SANDING) PAINTED SU RF. IF SUCH CNDTNS CANNOT BE
(ING 15)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:CONTROL ENVIR CONCS BELOW APPLIC STDS. USE ONLY
NIOSH APPROVED RESPIRATORS IN ACCORDANCE WITH OSHA STANDARD 29 CFR
1910.134.
Ventilation:PROVIDE DILUTION VENTILATION OR LOCAL EXHAUST TO PREVENT
BUILD-UP OF VAPORS.
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER .
IMPERVIOUS CLOTHING, APRON.
Work Hygienic Practices:WASH HANDS THOROUGHLY AFTER HNDLG, ESPECIALLY
BEFORE EATING OR SMOKING.
Supplemental Safety and Health
EXPLO HAZ:MIX IN AIR & ELEVATED TEMPS. CLSD CNTNRS MAY BURST IF EXPOS
TO EXTREME HEAT/FIRE. IN CLSD TANKS, WATER/FOAM MAY CAUSE
FROTHING/ERUPTION. CNDTNS TO AVOID:FREEZING, SPKS, OPEN FLAME.
MATLS TO AVOID:HYDROGEN FLUORIDE, MAGNESIUM, CAUSTICS, MINERAL
ACIDS, SODIUM, POTASSIUM. EFTS OF OVEREXP:CARCIN IN FEMALE (ING 7)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Evaporation Rate & Reference:NOT KNOWN
Solubility in Water:NOT KNOWN
Appearance and Odor:BARLEY WHITE.
Percent Volatiles by Volume:77.69
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS, ACIDS, REDUCING AGENTS, BASES, ALUMINUM, ZINC, METALS,
PEROXIDE, NITRIC ACID, HYDROFLUORIC ACID, (SUPDAT)
Stability Condition to Avoid:ELEVATED TEMPS, CONT W/OXIDIZING AGENT,
ALUMINUM/ZINC, ULTRAVIOLET LIGHT, HIGH CONC OF DUST, STOR NEAR
ACIDS, (SUPDAT)
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE, ACRID
FUMES, OXYGEN, ALDEHYDES, TOXIC GASES, ACIDS, PROPIONALDEHYDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH ALL APPLICABLE
REGULATIONS. AVOID DISCHARGE TO NATURAL WATERS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:SUNFLAME
CAGE:LO050
CAGE:LO050
CAGE:2F542
CAGE:86848
============= Composition/Information on Ingredients =============
Ingred Name:THORIUM NITRATE
RTECS #:XO6825000
===================== Hazards Identification =====================
Effects of Overexposure:LOW ORDER OF TOXICITY, MAY CAUSE HEMOLYSIS IN
BLOOD STREAM. INH: DOGS 2-10 WKS ABSORMAL LEVCOCY.
======================= First Aid Measures =======================
First Aid:EYE: WASH W/LG VOLUME WATER. SKIN: WASH W/SOAP & WATER. INH:
PROD IS NON VOLATILE. INGEST: INDUCE VOMIT.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER FOG
Fire Fighting Procedures:SELF-CNTND BRTHNG APPARATUS
Unusual Fire/Explosion Hazard:IN CNTCT W/EASILY OXIDIZABLE SUBST IT MAY
REACT RAPIDLY ENOUGH TO CAUSE IGNITION VIOLENT
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN UP IMMED & ISOLATE SPILLAGE IN STEEL
DRUM
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY PLACE. SEPARATE
FROM COMBUSTIBLE, ORGANIC OR OTHER READILY OXIDIZABLE MATL. AVOID
STG ON WOOD FLOORS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SELF-CNTND BRTHNG APPARATUS IN CASE OF FIRE.
WEAR MASK W/FILT
Ventilation:MAINTAIN ADEQUATE VENT. IF DUSTING, USE MECH.
Other Protective Equipment:NONE
Supplemental Safety and Health
ISOTOPE USED TO MAKE THORIUM NITRATE WAS THORIUM 232.
================== Physical/Chemical Properties ==================
HCC:A3
Solubility in Water:COMPLETE
Appearance and Odor:WHITE CRYSTALLINE, SOLID MP 932F DECOMP
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING MATL EASILY OXIDIZABLE MATL, ORGANIC
Stability Condition to Avoid:UNSTABLE @HI TEMPS, EG FIRES
Hazardous Decomposition Products:NITROGEN OXIDES EMITTED ON
DECOMPSITION
==================== Disposal Considerations ====================
Waste Disposal Methods:FOLLOW US AEC CFR 10 PART 20 & LOCAL HEALTH DEPT
REG. WASTE SHOULD BE TURNED OVER TO COMMERCIAL DISPOSAL AGY
HANDLING RADIOACTIVE WASTES.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:USA 310CB-15
CAGE:JO533
CAGE:0AZS7
CAGE:JO533
============= Composition/Information on Ingredients =============
Ingred Name:IRON
CAS:7439-89-6
RTECS #:NO4565500
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:NICKEL (SARA 313) (CERCLA) (MFR'S CAS #7440-02-2)
CAS:7440-02-0
RTECS #:QR5950000
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3
Ingred Name:MOLYBDENUM
CAS:7439-98-7
RTECS #:QA4680000
OSHA PEL:10 PPM
ACGIH TLV:10 PPM
Ingred Name:MANGANESE (SARA 313)
CAS:7439-96-5
RTECS #:OO9275000
OSHA PEL:5 MG/M3 DUST, C
ACGIH TLV:5 MG/M3 DUST
Ingred Name:CHROMIUM (SARA 313) (CERCLA)
CAS:7440-47-3
RTECS #:GB4200000
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SILICON
CAS:7440-21-3
RTECS #:VW0400000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:NIOBIUM; (COLUMBIUM)
CAS:7440-03-1
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:CALCIUM CARBONATE
CAS:1317-65-3
RTECS #:EV9580000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:CALCIUM FLUORIDE
CAS:7789-75-5
RTECS #:EW1760000
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SODIUM SILICATE
CAS:1344-09-8
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CLAY (KAOLIN); (ALUMINUM SILICATES)
CAS:1332-58-7
RTECS #:GF1670500
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:2 MG/M3 TDUST
Ingred Name:POTASSIUM SILICATES
CAS:1312-76-1
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CRYOLITE
CAS:15096-52-3
RTECS #:WA9625000
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ZIRCONIUM SILICATES
CAS:7440-42-6
RTECS #:9999999ZZ
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:COPPER (SARA 313) (CERCLA)
CAS:7440-50-8
RTECS #:GL5325000
OSHA PEL:0.1MG/M3 FUME;1 DUST
ACGIH TLV:0.2 MG/M3 FUME
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:SILICA, CRYSTALLINE - QUARTZ; (QUARTZ)
CAS:14808-60-7
RTECS #:VV7330000
OSHA PEL:N/K
ACGIH TLV:0.1 MG/M3 RDUST
Ingred Name:SUPDAT: BE REACHED BEFORE LIM OF 5 MG/M3 FOR GEN WELDING
FUMES IS REACHED. WATCH CR(VI) LEVEL. GASEOUS RXN PRODS(ING 19)
RTECS #:9999999ZZ
Ingred Name:ING 18:MAY INCL CO & CO*2. OZONE & NITROGEN OXIDES MAY BE
FORMED BY RADIA FROM ARC. CONTACT NEHC FOR MORE INFO .
RTECS #:9999999ZZ
Ingred Name:EXPLAN OF CARCIN:CRYSTALLINE-QUARTZ:IARC MONO, V 68,
1997:GRP 1. NTP 7TH ANNUAL RPT ON CARCINS, 1994:ANTIC TO BE CARCIN.
RTECS #:9999999ZZ
Ingred Name:EFTS OF OVEREXP: IN LUNG) & IS BELIEVED TO AFFECT PULM
FUNC. REPETITIVE EXPOS TO FLUORIDE FUMES &/OR GASES MAY (ING 22)
RTECS #:9999999ZZ
Ingred Name:ING 21: CAUSE EXCESS CALCIFICATION OF BONES & LIGAMENTS OF
RIBS, PELVIS & SPINAL COLUMN. CHROMIUM(VI) CMPDS MAY (ING 23)
RTECS #:9999999ZZ
Ingred Name:ING 22:CAUSE ULCERATION & PERFORATION OF NASAL SEPTUM &
LIVER & KIDNEY DMG. REPETITIVE OVEREXP TO NICKEL OXIDES (ING 24)
RTECS #:9999999ZZ
Ingred Name:ING 23: MAY LEAD TO LUNG FIBROSIS OR PNEUMOCONIOSIS. ARC
RAYS CAN INJURE EYES & BURN SKIN. ELEC SHOCK CAN KILL.
RTECS #:9999999ZZ
Ingred Name:EYE PROT:& FULL LNGTH FSHLD W/FILTER LENS SHADE
#12-14/DARKER. SHIELD OTHERS BY PROVIDING SCREENS & FLASH GOGGS.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE OVEREXP TO WELDING FUMES MAY
RSLT IN DISCOMFORT SUCH AS DIZZ, NAUS OR DRYNESS/IRRIT OF NOSE,
THROAT/EYES. INHAL OF EXTREMELY HIGH LEVELS OF FLUORIDES MAY CAUSE
ABDOM PAIN, DIARR, MUSC WEAK & CON VLS. CONTINUED INHAL COULD CAUSE
UNCON & DEATH. CHROMIUM (VI) CMPDS PRESENT IN FUME MAY CAUSE SEV
IRRIT(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NICKEL: IARC MONO, VOL 49, PG 257,
1990:GRP 2B. NTP 7TH ANNUAL RPT ON CARCINS, 1994:ANTIC TO BE
CARCIN. SILICA, (ING 20)
Effects of Overexposure:HLTH HAZ: OF BRONCH TUBES & LUNGS. INGEST OF
CHROMIUM (VI) SALTS MAY CAUSE INJURY/DEATH. CHROMIUM(VI) CMPDS MAY
BURN EYES. CHROMIUM CMPDS MAY CAUSE ALLERGIC RXNS. NICKEL OXIDES IN
FUME MAY CAUSE TIGHT NESS AROUND CHEST, FEVER & ALLERGIC RXNS.
CHRONIC OVEREXP TO WELDING FUMES CAN LEAD TO SIDEROSIS (IRON
DEPOSITS (ING 21)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST: CALL MD IMMED . EYES: IMMED FLUSH W/POTABLE WATER FOR
A MINIMUM OF 15 MINUTES, SEEK ASSISTANCE FROM MD . SKIN: FLUSH
W/COPIOUS AMTS OF WATER. CALL MD . CALL FOR MED ASSISTANC E. USE
FIRST AID PROCEDURERS RECOM BY AMERICAN RED CROSS. IF BREATHING IS
DFCLT, GIVE OXYGEN. IF NOT BREATHING USE CPR. CONSULT MD IF
IRRITATION OF EYES & SKIN OR FLASH BURNS DEVELOP AFTER EXPOSURE.
===================== Fire Fighting Measures =====================
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NON-FLAMMABLE: WELDING ARC AND SPARKS CAN
IGNITE COMBUSTIBLES. SEE Z-49.1 SAFETY IN WELDING & CUTTING,
PUBLISHED BY AWS, 550 NW LEJEUNE RD, MIAMI, FL 33126.
================== Accidental Release Measures ==================
Spill Release Procedures:NONE SPECIFIED BY MANUFACTURER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:READ & UNDERSTAND MFR'S INSTRUCTIONS &
PREC LABEL ON PROD. ADVISE WELDERS TO KEEP THEIR HEAD OUT OF FUMES.
SEE ANSI Z49.1 & 29 CFR 1910 FOR MORE INFO.
Other Precautions:ONE METHOD OF DETERMINING COMPOSITION & QTY OF FUMES
& GASES TO WHICH WORKERS ARE EXPOSED IS TO TAKE AIR SAMPLE FROM
INSIDE WELDER'S HELMET WHILE WORN OR IN WORKER'S BREATHING ZONE.
SEE ANSI/AWS F1.1 AVAIL FROM AMERICAN WELDING SOCIETY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED RESPIRABLE FUME RESPIRATOR OR
AIR SUPPLIED RESPIRATOR WHEN WELDING IN CONFINED SPACE OR GENERAL
WORK AREA WHERE LOCAL EXHAUST AND/OR VENTILATION DOES NOT KEEP
EXPOSURE BELOW THE THR ESHOLD LIMIT VALUE.
Ventilation:USE PLENTY OF VENT &/OR LOC EXHST AT ARC TO KEEP FUMES &
GASES BELOW TLV W/IN WORKER'S BRTHG ZONE & GEN WORK AREA.
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER . ARM
PROTECTORS, APRON, HATS, SHOULDER PROT & DARK SUBSTANTIAL CLTHG.
Work Hygienic Practices:TRAIN WELDER NOT TO ALLOW ELEC LIVE PARTS TO
GROUND.
Supplemental Safety and Health
HAZ DECOMP PRODS: WELDED, PROCS FOLLOWED & ELECTRODES USED. REASONABLE
EXPECTED FUME CONSTITUENTS OF PROD WOULD INCL: COMPLEX OXIDES OF
ALUMINUM, IRON, MANGANESE, SILICON, TITANIUM, CHROMIUM, NICKEL,
CALCIUM, COLUMBIAN, MOLYBDENUM & COPPER. FLUORIDES WILL ASLO BE
PRESENT. FUME LIM FOR (CR(VI)(0.05 MG/M3) MAY (ING 18)
================== Physical/Chemical Properties ==================
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:WELDING FUMES & GASES CANNOT BE
CLASSIFIED SIMPLY. COMPOSITION & QTY OF FUMES & GASES DEPEND ON
METAL BEING (SUPDAT)
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCARD ANY PRODUCT, RESIDUE, DISPOSAL CONTAINER
OR LINER IN AN ENVIRONMENTALLY ACCEPTABLE MANNER APPROVED BY
FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:ARGON, LAR (LIQUID ONLY)
CAGE:00742
CAGE:00742
CAGE:5H199
============= Composition/Information on Ingredients =============
Ingred Name:ARGON
CAS:7440-37-1
RTECS #:CF2300000
ACGIH TLV:ASPHYXIANT; 9192
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ARGON IS NONTOXIC BUT CAN ACT AS A
SIMPLE ASPHYXIANT BY DISPLACING THE AMOUNT OFOXYGEN IN THE AIR
NECESSARY TO SUPPORT LIFE.
Effects of Overexposure:ARGON IS ODORLESS & NONTOXIC,BUT MAY PRODUCE
SUFFOCATION BY DILUTING THE CONCENTRATION OF OXYGEN IN AIR.EXPOSURE
TO OXYGEN-DEFICIENT ATMOSPHERES MAY PRODUCE
DIZZINESS,NAUSEA,VOMITING,LOSS OF CONSCIOUS NESS,& DEATH.DEATH MAY
RESULT FROM ERRORS IN JUDGEMENT,CONFUSION,OR LOSS OF CONSCIOUSNESS
WHICH PREVENTS SELF-RESCUE.
======================= First Aid Measures =======================
First Aid:PERSONS EXPOSED SHOULD BE MOVED TO NORMAL
ATMOSPHERES.ASSISTED RESPIRATION & SUPPLEMENTAL OXYGEN SHOULD BE
GIVEN IF THE VICTIM IS NOT BREATHING.IF CRYOGENIC LIQOR COLD
BOIL-OFF GAS CONTACTS A WORKER'S SKIN OR EYES,FROZEN TISSUES
WHOULD BE FLOODED OR SOAKED W/TEPID WTR.DO NOT USE HOT
WTR.CRYOGENIC BURNS WHICH RESULT IN BLISTERING OR DEEPER TISSUE
FREEZING SHOULD BE SEEN PROMPTLY BY A PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:NA
Lower Limits:NA
Upper Limits:NA
Extinguishing Media:NA
Fire Fighting Procedures:NA
Unusual Fire/Explosion Hazard:NA
================== Accidental Release Measures ==================
Spill Release Procedures:AVOID CONTACT OF SKIN W/LIQ ARGON OR ITS COLD
BOIL-OFF GAS.FLUSH LIQ ARGON SPILL W/WTR TO DISPERSE.VENTILATE
ENCLOSED AREAS TO PREVENT FORMATION OF OXYGEN-DEFICIENT ATMOSPHERE
CAUSED BY THE EVAP OF LI Q ARGON OR THE RELEASE OF GASEOUS ARGON.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID DRAGGING,ROLLING,OR SLIDING
CYLS,EVEN FOR A SHORT DISTANCE.USE A SUITABLE HAND TRUCK.STORE IN
WELL VENTILATED AREA.SEGREGATE FULL/EMPTY CYLS.
Other Precautions:LIQ ARGON IS CRYOGENIC LIQ.MATERIALS OF CONSTRUCTION
MUST BE SELECTED FOR COMPATIBILITY W/EXTREMELY LOW
TEMPERATURES.AVOID USE OF CARBON STEEL AND OTHER MATERIALS WHICH
BECOME BRITTLEAT LOW TEMPERATUR ES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE A SELF-CONTAINED BREATHING APPARATUS IN
OXYGEN-DEFICIENT ATMOSPHERE.CAUTION!RESPIRATORS WILL NOT
FUNCTION.USE MAY RESULT IN ASPHYXIATION.
Ventilation:NATURAL/MECHANICAL WHERE GAS OR VAPORS ARE PRESENT.VENTS
SHOULD BE SITUATED TO AVOID HIGHER THAN NORM CONCENTRATION.
Other Protective Equipment:NONE
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:-302.6F
Vapor Pres:NA
Vapor Density:@68F 20C
Spec Gravity:@68F 20C
Solubility in Water:@68F 20C
Appearance and Odor:BOTH LIQUID & GASEOUS ARGON ARE COLORLESS &
ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:ALLOW LIQ TO EVAP IN A WELL VENTILATED OUTDOOR
LOCATION REMOTE FROM WORK AREAS.VENT ARGON GAS SLOWLYTO A WELL
VENTILATED OUTDOOR LOCATION REMOTE FROM WORK AREAS.DO NOT ATTEMPT
TO DISPOSE OF RESIDUAL A RGON IN COMPRESSED GAS CYLS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:NATURAL GAS
Preparer's Name:RICH GUFFEY
CAGE:0CEX1
CAGE:0CEX1
============= Composition/Information on Ingredients =============
Ingred Name:METHANE
CAS:74-82-8
RTECS #:PA1490000
Fraction by Wt: 94.1%
Other REC Limits:NONE RECOMMENDED
ACGIH TLV:ASPHYXIANT; 9293
Ingred Name:ETHANE
CAS:74-84-0
RTECS #:KH3800000
Fraction by Wt: 3.1%
Other REC Limits:NONE RECOMMENDED
ACGIH TLV:ASPHYXIANT 9293
Ingred Name:N-BUTANE
CAS:106-97-8
RTECS #:EJ4200000
Fraction by Wt: 0.2%
Other REC Limits:NONE RECOMMENDED
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 0.8%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT; 9293
Ingred Name:ALKYL MERCAPTANS
Fraction by Wt: 0.01%
Other REC Limits:NONE RECOMMENDED
Ingred Name:ISO-BUTANE
CAS:75-28-5
RTECS #:TZ4300000
Fraction by Wt: 0.2%
Other REC Limits:NONE RECOMMENDED
Ingred Name:ISOPENTANE
CAS:78-78-4
RTECS #:EK4430000
Fraction by Wt: 0.1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:N-PENTANE (PENTANE)
CAS:109-66-0
RTECS #:RZ9450000
Fraction by Wt: 0.1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:120 PPM
Ingred Name:CARBON DIOXIDE
CAS:124-38-9
RTECS #:FF6400000
Fraction by Wt: 3%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10000PPM/30000STEL
ACGIH TLV:5000PPM/30000STEL;93
Ingred Name:NITROGEN
CAS:7727-37-9
RTECS #:QW9700000
Fraction by Wt: 2%
Other REC Limits:NONE RECOMMENDED
ACGIH TLV:ASPHYXIANT; 9293
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION IS THE MAJOR AND
POSSIBLY ONLY ROUTE OF ENTRY INTO THE BODY. IT IS CONSIDERED A
SIMPLE ASPHYXIANT.SKIN CONTACT WITH LIQUID MAY CAUSE FREEZE
BURNS. CHRONIC: NONE SPECIFIED BY MANUFA CTURER.
Explanation of Carcinogenicity:NO INGREDIENT OF A CONCENTRATION OF 0.1%
OR GREATER IS LISTED AS A CARCINOGEN OR SUSPECTED CARCINOGEN.
Effects of Overexposure:DIZZINESS, CYANOSIS, DIMINISHED MENTAL
CAPACITY, COLLAPSE, LOSS OF CONSCIOUSNESS, AND/OR DEATH. CONTACT
WITH LIQUID CAN PRODUCE FREEZE BURNS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. QUICKLY RESTORE AND/OR
SUPPORT BREATHING AS REQUIRED; GIVE ARTIFICIAL RESPIRATION
IMMEDIATELY. ADMINISTER OXYGEN IF AVAILABLE. SKIN: WARM INJURED
AREA; TREAT AS FROSTB ITE. GET IMMEDIATE MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:-306F,-188C
Lower Limits:3.6%
Upper Limits:17%
Extinguishing Media:CARBON DIOXIDE OR DRY CHEMICAL. STOP FLOW OF GAS
BEFORE EXTINGUISHING.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE GEAR. USE WATER SPRAY TO COOL FIRE EXPOSED
CONTAINERS AND SURROUNDINGS.
Unusual Fire/Explosion Hazard:EXTREMELY FLAMMABLE AND READILY FORMS
EXPLOSIVE MIXTURES WITH AIR. IN PRESENCE OF CATALYST OR SOURCES OF
IGNITION, VIOLENT OR EXPLOSIVE REACTIONS W/OXIDIZERS.
================== Accidental Release Measures ==================
Spill Release Procedures:NOTIFY SAFETY PERSONNEL; EVACUATE AREA.
VENTILATE AREA. ELIMINATE ALL SOURCES OF IGNITION. SHUT OF LEAK.
TEST ATMOSPHERE PRIOR TO ENTRY. CHECK FOR LEAKS USING SOAPY WATER.
WEAR PROPER RESPIRATORY PROT ECTION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:GROUND ALL LINES AND EQUIPMENT USED
AROUND OR ON NATURAL GAS TO PREVENT SPARKS. USE NON-SPARKING
TOLLS. NO SMOKING.
Other Precautions:19% OXYGEN CONTENT REQUIRED FOR OPERATIONS WITHOUT
SCBA; USE OF SCBA REQUIRED IF BELOW 19% OXYEGN CONTENT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE USE NIOSH/MSHA APPROVED SELF-CONTAINED
BREATHING APPARATUS IF OXYGEN CONTENT BELOW 19%. USE IN ACCORDANCE
WITH 29 CFR 1910.134.
Ventilation:PROVIDE ADEQUATE DILUTION VENTIALTION TO PREVENT AIR
CONCENTRATIONS FROM REACHING 25% OF LEL OR THE TLV.
Other Protective Equipment:OVERALLS OR SIMILAR CLOTHES TO PREVENT
CONTACT OF LIQUID WITH SKIN.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:G2
Boiling Pt:B.P. Text:-184F,-120C
Melt/Freeze Pt:M.P/F.P Text:-182F,-119C
Vapor Density:0.6(AIR=1)
Spec Gravity:0.55 (AIR=1)
Appearance and Odor:COLORLESS, ODORLESS GAS UNLESS MERCAPTAN ADDED;
THEN SMELLS OF ROTTEN CABBAGE
Percent Volatiles by Volume:98.9
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS, AIR, HALOGENS
Stability Condition to Avoid:EXPOSURE TO HEAT, FLAME, OXIDIZERS,
HALOGENS AND AIR.
Hazardous Decomposition Products:BROMINE PENTAFLUORIDE, CHLORINE,
CHLORINE DIOXIDE, NITROGEN TRIFLUORIDE, OXYGEN DIFLUORIDE, LIQUID
OXYGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:FLUOROCARBON 11
Preparer's Name:DR W BROCK
CAGE:18873
CAGE:18873
============= Composition/Information on Ingredients =============
Ingred Name:METHANE, TRICHLOROFLUORO ("FREON" 11) (SARA III)
CAS:75-69-4
RTECS #:PB6125000
Fraction by Wt: 100%
Other REC Limits:NONE SPECIFIED
OSHA PEL:1000 PPM
ACGIH TLV:C, 1000 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ozone Depleting Chemical:1
===================== Hazards Identification =====================
LD50 LC50 Mixture:INHAL 4-HR LC50: 26,200 PPM (RAT)
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE CONTACT WITH VAPOR MAY CAUSE EYE
IRRITATION. SKIN CONTACT WITH LIQUID MAY CAUSE SKIN DRYING
W/REPEATED CONTACT RESULTING IN MILD SKIN IRRITATION W/DISCOMFORT
OR RASH. INHALATION MAY CAUSE TEMPORAR Y NERVOUS SYSTEM DEPRESSION
W/ANETHETICEFFECTS. TEMPO
Explanation of Carcinogenicity:NONE OF THE COMPONENTS IN THIS MAT'L IS
LISTED. ORAL ALD: 3725 MG/KG (RATS).
Effects of Overexposure:EYE: DISCOMFORT, TEARING, BLURRING OF VISION.
INHALATION: NERVOUS SYSTEM DEPRESSION: DIZZINESS, HEADACHE,
CONFUSION, INCOORDINATION AND LOSS OF CONSCIOUSNESS. IRREGULAR
PULSE, PALPITATIONS, INADEQUATE CIRCULATION, OR THE EFFECTS OF
EXCLUSION OF OXYGEN W/
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH PREEXISTING
DISEASES OF THE CENTRAL NERVOUS OR CARDIOVASCULAR SYSTEM MAY HAVE
INCREASED SUSCEPTIBILITY TO THE TOXICITY OF EXCESSIVE EXPOSURES.
======================= First Aid Measures =======================
First Aid:INHALATION: IMMEDIATELY REMOVE TO FRESH AIR. KEEP PERSONS
CALM. IF NOT BREATHING, GIVE ARTIFICIAL RESPIRATION. IF BREATHING
IS DIFFICULT, GIVE OXYGEN. CALL DR. SKIN: FLUSH W/WATER. TREAT FOR
FROSTBITE IF NECESSARY BY GENTLY WARMING AFFECTED AREA. EYE: IM
===================== Fire Fighting Measures =====================
Flash Point Method:TOC
Flash Point:WILL NOT BURN
Extinguishing Media:AS FOR COMBUSTIBLES IN AREA.
Fire Fighting Procedures:SELF-CONTAINED BREATHING APPARATUS (SCBA IS
REQUIRED IF CONTAINERS RUPTURE AND CONTENTS ARE SPILLED UNDER FIRE
CONDITIONS.
Unusual Fire/Explosion Hazard:DRUMS MAY RUPTURE UNDER FIRE CONDITIONS.
DECOMPOSITION MAY OCCUR.
================== Accidental Release Measures ==================
Spill Release Procedures:REVIEW FIRE & EXPLOS HAZARDS & SAFETY
PRECAUTIONS BEFORE PROCEEDING W/CLEAN UP. USE PERSONAL PROTECT
EQUIP DURING CLEAN UP. VENT AREA. DON'T FLUSH INTO SEWERS. DIKE
SPILL. COLLECT ON ABSORB MAT'L. TRA NSFER TO STEEL DRUMS. LRG
SPILL, USE SCBA.
Neutralizing Agent:N/K COMPLY WITH FEDERAL, STATE AND LOCAL REGULATIONS
ON REPORTING RELEASES.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN CLEAN, DRY AREA. DO NOT HEAT
ABOVE 125F. USE WITH SUFFICIENT VENTILATION TO KEEP EMPLOYEE
EXPOSURE BELOW RECOMMENDED LIMITS.
Other Precautions:N/K AS EPINEPHRINE, SHOULD BE USED WITH SPECIAL
CAUTION IN SITUATIONS OF EMERGENCY LIFE SUPPORT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:UNDER NORMAL MANUFACTURING CONDITIONS, NO
RESPIRATORY PROTECTION IS REQUIRED WHEN USING THIS PRODUCT.
SELF-CONTAINED BREATHING APPARATUS (SCBA) IS REQUIRED IF A LARGE
RELEASE OCCURS.
Ventilation:NORMAL VENT FOR STD MFR PROCEDURES IS GEN ADEQUATE. LOCAL
EXHAUST WHEN LRG AMTS ARE RELEASED. MECHAN VENT IN LOW PLACES.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:75.0F,23.9C
Decomp Temp:Decomp Text:>1100F,>593
Vapor Pres:14.7 PSIA
Vapor Density:4.9
Spec Gravity:1.48 G/CC @ 25C
pH:NEUTRL
Evaporation Rate & Reference:>1 (CC14=1)
Solubility in Water:0.1 WT% @ 25C
Appearance and Odor:COLORLESS, CLEAR LIQUEFIED GAS, SLIGHT ETHEREAL
ODOR.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
INCOMPATIBLE WITH ALKALI OR ALKALINE EARTH METALS- POWDERED AL, ZN, BE,
ETC.
Stability Condition to Avoid:AVOID OPEN FLAMES AND HIGH TEMPERATURES.
Hazardous Decomposition Products:BY HIGH TEMPS FORMING: HYDROCHLORIC &
HYDROFLUORIC ACIDS-POSSIBLY CARBONYL HALIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:RECLAIM BY DISTILLATION OR REMOVE TO A PERMITTED
WASTE DISPOSAL FACILITY. COMPLY WITH FEDERAL, STATE & LOCAL
REGULATIONS. RPT QTY: 5000 LBS/2270 KG.
| 1 |
gloves_mandatory
|
=======================================================
Product ID: NON-MELT GREASE, 7062
Cage: 0SFY9
Resp. Party Other MSDS No.: COURQR0420
=======================================================
Contractor Summary
=======================================================
Cage: 0SFY9
=======================================================
Ingredients
=======================================================
> Wt: 50.
Other REC Limits: NOT ESTABLISHED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: NOT ESTABLISHED
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: LD50ORAL/RAT-4673MG/KG;RABBIT >2000MG/KG
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: EMERGENCY OVERVIEW: CAUTION: EYE AND SKIN IRRITANT. AVOID
EYE CONTACT. MAY BE HARMFUL IF SWALLOWED. PRIMARY ROUTES OF EXPOSURE: SKIN
CONTACT. REFER TO SIGNS & SYMPTOMS OF OVEREXPOSURE FOR ADDITIONA L
HEALTH HAZARDS INFORMATION (FP N).
Explanation Of Carcinogenicity: OSHA REGULATED: N/P. ACGIH: N/P. NATIONAL
TOXICOLOGICAL PROGRAM: N/P. CANCER-SUSPECT CONSTITUENT(S): NONE.
Signs And Symptions Of Overexposure: SYMPTOMS OF ACUTE OVEREXPOSURE: SKIN: MAY
CAUSE MILD IRRITATION. INHALATION: MILD NASAL IRRITATION ON REPEATED
EXPOSURE. EYES: MILD IRRITATION ON REPEATED EXPOSURE TO VAPOR. INGESTION: NO
DATA. EFFEC TS OF CHRONIC OVEREXPOSURE: FREQUENTLY REPEATED EXPOSURE MAY
CAUSE DEFATTING OF SKIN. OTHER EFFECTS: NONE KNOWN.
Medical Cond Aggravated By Exposure: NONE REPORTED.
First Aid: EYES: FLUSH WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES, CALL A
PHYSICIAN. SKIN: REMOVE CONTAMINATED CLOTHING; WASH AFFECTED SKIN WITH SOAP
AND WATER. LAUNDER CLOTHING BEFORE WEARING AGAIN. INHALATIO N: MOVE TO FRESH
AIR, GET MEDICAL ATTENTION IF SYMPTOMS PERSIST. INGESTION: IF PATIENT IS
CONSCIOUS, GIVE WATER AND INDUCE VOMITING. CALL A PHYSICIAN.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: SPILL CONTROL: AVOID PERSONAL CONTACT. ELIMINATE
IGNITION SOURCES. VENTILATE AREA. CONTAINMENT: DIKE, CONTAIN AND ABSORB WITH
CLAY, SAND, OR OTHER SUITABLE MATERIAL. CLEANUP: FOR LARGE SPILLS, PUMP TO
STORAGE/ SALVAGE VESSELS. SOAK UP RESIDUE WITH AN ABSORBENT SUCH AS CLAY,
SAND, OR OTHER SUITABLE MATERIAL & DISPOSE OF PROPERLY. FLUSH AREA WITH
WATER TO REMOVE TRACE RESIDUE. (OTHER INFORMATION)
Waste Disposal Methods: WASTE MANAGEMENT RECOMMENDATIONS: IF THIS MATERIAL
BECOMES A WASTE, IT WOULD NOT BE A HAZARDOUS WASTE BY RCRA CRITERIA (40 CFR
261). DISPOSE OF ACCORDING TO APPLICABLE FEDERAL, STATE AND LOCAL REGULAT
IONS.
Handling And Storage Precautions: HANDLING PRECAUTIONS: AVOID PROLONGED OR
REPEATED CONTACT WITH SKIN OR EYES. WASH THOROUGHLY AFTER HANDLING. STORAGE
PRECAUTIONS: STORE IN A COOL, VENTILATED AREA AWAY FROM IGNITION SOURCES.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: COC
Flash Point: =204.4C, 400.F
Lower Limits: N/D
Upper Limits: N/D
Extinguishing Media: CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures: SEVERE FIRE MAY REQUIRE SELF-CONTAINED BREATHING
APPARATUS (NIOSH APPROVED - FP N) AND PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard: WATER OR FOAM MAY CAUSE FROTHING. TOXIC SMOKE OR
VAPORS MAY FORM DURING COMBUSTION. HAZARDOUS PRODUCTS OF COMBUSTION: CARBON
MONOXIDE, CARBON DIOXIDE. OTHER UNKNOWN ORGANIC COMPOUNDS.
=======================================================
Control Measures
=======================================================
Respiratory Protection: WHEN VENTILATION IS INADEQUATE, USE NIOSH APPROVED
RESPIRATOR FOR ORGANIC MISTS AND VAPORS. WITH GOOD VENTILATION, NONE
REQUIRED.
Ventilation: GENERAL MECHANICAL VENTILATION IN ENCLOSED AREAS.OTHER
ENGINEERING CONTROLS: N/A.
Other Protective Equipment: RUBBER OR PLASTIC APRON AS REQUIRED.
=======================================================
Physical/Chemical Properties
=======================================================
Boiling Point: >315.6C, 600.F
M.P/F.P Text: N/D
Vapor Pres: <<1 (MM HG @ 68F)
Vapor Density: 11.8,AIR=1
Spec Gravity: < 1
PH: N.D.
Solubility in Water: INSOLUBLE
Appearance and Odor: RED PASTE WITH MILD PETROLEUM ODOR.
Percent Volatiles by Volume: 0
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: HEAT, HEATED SURFACES, STATIC ELECTRICITY,
SPARKS, FLAMES.
Materials To Avoid: STRONG OXIDIZING AGENTS, BLEACHING AGENTS, ACIDS.
Hazardous Decomposition Products: CARBON MONOXIDE, CARBON DIOXIDE, OTHER
UNKNOWN ORGANIC COMPOUNDS.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NONE.
=======================================================
Toxicological Information
=======================================================
Toxicological Information: ACUTE ORAL EFFECTS: LD50 (RAT): 4673 MG/KG; NO DATA
AVAILABLE. ACUTE DERMAL EFFECTS: LD50 (RABBIT): >2000 MG/KG; NO DATA
AVAILABLE. ACUTE INHALATION EFFECTS - LC50 (RAT): >200 MG/LITER IN 0
HOURS; N O DATA AVAILABLE. SUBCHRONIC EFFECTS: NONE KNOWN. CARCINOGENICITY,
TERATOGENICITY, AND MUTAGENICITY: NONE KNOWN. CHRONIC EFFECTS: NONE KNOWN.
EYE IRRITATION: NO DATA AVAILABLE. TOXICOLOGICAL INFO RMATION ON HAZARDOUS
CHEMICAL CONSTITUENTS OF THIS PRODUCT: CONSTITUENT: MINERAL OIL, ORAL LD50
(RAT): N/D, DERMAL LD50 (RABBIT): N/D, INHALATION LC50 (RAT, 4 HOURS): N/D.
=======================================================
Ecological Information
=======================================================
Ecological: ECOTOXICITY: NO DATA AVAILABLE. MOBILITY AND PERSISTENCE: NO DATA
AVAILABLE. ENVIRONMENTAL FATE: NO DATA AVAILBLE.
=======================================================
=======================================================
Transport Information: PROPER SHIPPING NAME: NON-REGULATED MATERIAL. TECHNICAL
NAME: N/P. HAZARD CLASS: NONE. UN NUMBER: N/A. PACKING GROUP: N/A. IMDG
PAGE NO.: N/A. EMERGENCY RESPONSE GUIDE NO.: N/A.
=======================================================
Regulatory Information
=======================================================
Sara Title III Information: CLASSIFICATION OF THIS MATERIAL FOR SARA SECTION
312 HAZARDOUS MATERIALS INVENTORY REPORTING: NONE. CONSULT THE APPROPRIATE
REGULATIONS FOR EMERGENCY PLANNING AND RELEASE REPORTING REQUIREMENTS FOR S
UBSTANCES ON THE SARA SECTION 301 EXTREMELY HAZARDOUS SUBSTANCES LIST.
Federal Regulatory Information: TSCA: ALL INGREDIENTS OF THIS PRODUCT ARE
LISTED, OR ARE EXEMPT FROM LISTING ON THE TSCA INVENTORY. THE FOLLOWING RCRA
CODE(S) APPLIES TO THIS MATERIAL IF IT BECOMES WASTE: NONE. REGULATORY
STATUS O F HAZARDOUS CHEMICAL CONSTITUENT OF THIS PRODUCT: CONSTITUENT:
MINERAL OIL: EXTREMELY HAZARDOUS: NO; TOXIC CHEMICAL: NO; CERCLA RQ (LBS):
NO; TSCA 128 EXPORT NOTIFICATION: NOT REQUIRED. CANADIAN REG ULATIONS: W
HAZARD CLASS(ES): NONE. ALL COMPONENTS OF THIS PRODUCT ARE ON THE DOMESTIC
SUBSTANC ES LIST.
=======================================================
Other Information
=======================================================
Other Information: HAZARDOUS MATERIALS INFORMATION SYSTEM () RATINGS: HEALTH -
1, FLAMMABILITY - 1, REACTIVITY - 1. CHEMICAL FAMILY: MINERAL OIL.
PHYSICAL / CHEMICAL PROPERTIES (CONT): PERCENT SOLIDS BY WEIGHT: 100. PH
(5% SOLUTION OR SLURRY IN WATER): N.D. ADDITIONAL INFORMATION ON
INGREDIENTS EXPOSURE LIMITS: "N/E" INDICATES THAT NO EXPOSURE LIMIT HAS BEEN
ESTABLISHED. SPILL / RELE ASE PROCEDURES (CONT): SPECIAL PROCEDURES:
PREVENT SPILL FROM ENTERING DRAINAGE / SEWER SYSTEMS, WATERWAYS AND SURFACE
WATERS.
=======================================================
HAZCOM Label
=======================================================
Product ID: NON-MELT GREASE, 7062
Cage: 0SFY9
Company Name: ITW PHILADELPHIA RESINS CORPORATION
Street: 130 COMMERCE DR.
Zipcode: 18936
Label Required IND: Y
Date Of Label Review: 08/02/2001
Status Code: A
Origination Code: F
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: ACUTE: EYE AND SKIN IRRITANT. AVOID EYE CONTACT. MAY BE
HARMFUL IF SWALLOWED. MAY CAUSE MILD SKIN IRRITATION. MAY CAUSE MILD EYE
IRRITATION ON REPEATED EXPOSURE TO VAPOR. MAY CAUSE MILD NASAL IRRITATI ON ON
REPEATED EXPOSURE. CHRONIC: FREQUENTLY REPEATED EXPOSURE MAY CAUSE DEFATTING
OF THE SKIN.
=======================================================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:MICROPURE CDF
CAGE:0SXX1
CAGE:46575
CAGE:0LFH2
CAGE:0SXX1
============= Composition/Information on Ingredients =============
Ingred Name:1-METHYLPYRROLIDONE
CAS:872-50-4
RTECS #:UY5790000
Fraction by Wt: 40-70% %
Other REC Limits:100 PPM
Ingred Name:DIPROPYLENE GLYCOL METHYL ETHER
CAS:34590-94-8
RTECS #:JM1575000
Fraction by Wt: 40-70% %
Other REC Limits:NONE RECOMMENDED
OSHA PEL:S,100PPM
ACGIH TLV:S,100PPM/150STEL; 94
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 ORAL >5000 MG/KG (RAT)
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NO EFFECTS EXPECTED FROM INGESTION
EXPOSURE. NO EFFECTS OF INHALATION EXPOSURE EXPECTED. IF MISTED AT
HIGH CONCENTRATIONS, MAY CAUSE PALLOR, NAUSEA, ANESTHETIC OR
NARCOTIC EFFECTS. PROLONGED OR REPEAT ED SKIN CONTACT CAUSES
REDNESS, SWELLLING, CRACKING. VAPORS/SPLASHES IRRITATE EYES. CAUSE
PAINFUL BURNING OF EYES.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:PALLOR, NAUSEA, ANESTHETIC/NARCOTIC EFFECTS,
REDNESS/SWELLING/CRACKING OF THE SKIN, EYE IRRITATION, PAINFUL
BURNING OR STINGING OF THE EYES AND EYELIDS, WATERING OF EYES AND
INFLAMMATION OF CONJUNCTIV A.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGESTION: INDUCE VOMITING IMMEDIATELY BY GIVING TWO GLASSES
OF WATER AND STICKING FINGER DOWN THROAT. NEVER GIVE ANYTHING BY
MOUTH IF UNCONSCIOUS. CALL A PHYSICIAN. INHALATION: REMOVE TO FRESH
AIR. I F NOT BREATHING OR BREATHING IS DIFFICULT, CALL A PHYSICIAN.
SKIN: WASH WITH SOAP AND WATER. CALL A PHYSICIAN. EYES: IMMEDIATELY
FLUSH WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES. CALL A
PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:191F,88C
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:WATER, ALCOHOL FOAM, DRY CHEMICAL, CARBON DIOXIDE
Fire Fighting Procedures:FIRE FIGHTERS SHOULD WEAR POSITIVE PRESSURE,
FULL FACE, SELF-CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED
CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:AFTER FIRE IS EXTINGUISHED, MATERIAL
VAPORS COULD ACCUMULATE, TRAVEL TO SOURCE OF IGNITION AND FLASH
BACK. FIRE HAZARD WHEN EXPOSED TO HEAT, SPARKS OR FLAMES.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE SOURCES OF IGNITION. ABSORB WITH
EARTH, SAND OR SIMILAR INERT MATERIAL AND DISPOSE OF ACCORDING TO
FEDERAL, STATE AND LOCAL REGULATIONS. FLUSH SPILL AREA WITH A WATER
SPRAY.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTACT WITH EYES, SKIN AND
CLOTHING. WASH THOROUGHLY AFTER HANDLING. AT HIGH CONCENTRATIONS,
USE WITH ADEQUATE VENTILATION. KEEP CLOSED.
Other Precautions:WASH EQUIPMENT THOROUGHLY WITH STEAM OR WARM WATER
UNTIL CLEAN. CHECK FOR FLAMMABLES WITH AN EXPLOSION METER AND ALSO
CHECK THE OXYGEN LEVEL WITH OXYGEN METER. IN ALL CASES, FOLLOW GOOD
INDUSTRIAL SAF ETY PRACTICES BEFORE ENTERING EQUIPMENT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH-APPROVED RESPIRATOR, WHERE TLV OR PEL MAY
BE EXCEEDED.
Ventilation:AT HIGH CONCENTRATIONS, USE WITH ADEQUATE VENTILATION.
Other Protective Equipment:EMERGENCY EYEWASH STATION AND SHOWER.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
KEEP CONTAINER AND VAPORS FROM THIS CONTAINER AWAY FROM HEAT, SPARKS
AND FLAME. WASH CONTAMINATED CLOTHING BEFORE REUSE.
================== Physical/Chemical Properties ==================
HCC:B3
Boiling Pt:B.P. Text:363F,184C
Melt/Freeze Pt:M.P/F.P Text:-11F,-24C
Vapor Pres:< 1.00
Vapor Density:3.40
Spec Gravity:0.99-1.01
pH:9.20
Evaporation Rate & Reference:NOT GIVEN
Solubility in Water:MISCIBLE
Appearance and Odor:TRANSPARENT YELLOW, WATER-THIN LIQUID, SLIGHTLY
AMINE ETHER-LIKE ODOR
Percent Volatiles by Volume:100%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING OR REDUCING AGENTS
Stability Condition to Avoid:HEAT, FIRE, IGNITION SOURCES. AVOID
HEATING ABOVE FLASH POINT.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
OXIDES OF NITROGEN, SMOKE
==================== Disposal Considerations ====================
Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT, RESIDUE, DISPOSAL CONTAINER OR
LINER IN ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:CYCLOCORT CREAM
Preparer's Name:CHRISTINA J.BARRINGTON
CAGE:0K706
CAGE:0K706
============= Composition/Information on Ingredients =============
Ingred Name:CYCLOCORT
CAS:51022-69-6
RTECS #:TU3682500
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT) IS >2GM/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN:MAY CAUSE IRRITATION.POSSIBLE
ABSORPTION.EYES:MAY CAUSE IRRITATION.INHAL:POWDER MAY CAUSE
RESPIRATORY IRRITATION.
Explanation of Carcinogenicity:THERE ARE NO INGREDIENTS ABOVE 0.1%
WHICH ARE IDENTIFIED AS CARCINOGENS BY NTP,IARC OR OSHA.
Effects of Overexposure:EYE/SKIN/RESPIRATORY IRRITATION.
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN AND
RESPIRATORY AILMENTS MAY BE AT INCREASED RISK FROM EXPOSURE.
======================= First Aid Measures =======================
First Aid:SKIN:REMOVE CONTAMINATED CLOTHING;WASH WITH WATER.EYES:FLUSH
WITH WATER FOR 15 MINUTES.INHAL:REMOVE TO FRESH AIR.GIVE OXYGEN OR
CARDIOPULMONARY RESCUSITATION IF NEEDED.INGEST:GET PROMPT QUALIFIED
MEDI CAL ATTENTION.WASH MOUTH OUT WITH WATERAS SOON AS POSSIBLE.FOR
ADVERSE DRUG REACTIONS,CALL 708-317-5937.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WATER SPRAY,DRY CHEMCIAL,CARBON DIOXIDE,FOAM OR AS
APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures:USE A SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE EQUIPMENT.COOL FIRE EXPOSED CONTAINERS WITH WATER
SPRAY.
Unusual Fire/Explosion Hazard:MANUFACTURER STATES NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PROTECTIVE EQUIPMENT.USE ABSORBANT
TOWELS TO CLEAN UP SPILL;PLACE WASTE IN AN APPROPRIATE LABELED
CONTAINER FOR DISPOSAL.WIPE SURFACES CLEAN;WASH WITH SOAP AND
WATER.
Neutralizing Agent:NONE
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID INHALATION OF DUST/FUMES.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE WITH ADEQUATE VENTILATION.
Ventilation:LOCAL VENTILATION AT THE WORKSITE;MECHANICAL(GENERAL)
VENTILATION TO MAINTAIN TLV/PEL.
Other Protective Equipment:DISPOSABLE GARMENTS IF SKIN CONTACT IS
ANTICIPATED.PROVIDE LOCAL EYE WASH STATION.
Work Hygienic Practices:USE REASONABLE CARE IN HANDLING THIS ITEM.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:N1
Solubility in Water:COMPLETE
Appearance and Odor:CREAM;COLOR AND ODOR NOT REPORTED.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL,STATE AND
LOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:KX-PDP1,NO.B-10, BLACK DEVELOPER
Kit Part:Y
CAGE:55643
CAGE:0S0F8
CAGE:S5643
CAGE:61058
CAGE:55643
CAGE:47642
============= Composition/Information on Ingredients =============
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: 0.2%
Other REC Limits:NONE SPECIFIED
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3 9293
Ingred Name:FERRITE CONTAINING INGRIENTS NUMBERS 3, 4, AND 5
RTECS #:9999999ZZ
Fraction by Wt: 95.5%
Other REC Limits:NONE SPECIFIED
Ingred Name:IRON OXIDE
CAS:1309-37-1
RTECS #:NO7400000
Other REC Limits:NONE SPECIFIED
OSHA PEL:10 MG/M3 (FE)
ACGIH TLV:5 MG/M3(FE),B2; 9293
Ingred Name:COPPER OXIDE
CAS:1317-38-0
RTECS #:GL7900000
Other REC Limits:NONE SPECIFIED
Ingred Name:ZINC OXIDE
CAS:1314-13-2
RTECS #:ZH4810000
Other REC Limits:NONE SPECIFIED
OSHA PEL:15MG/M3 TDUST/5 FUME
ACGIH TLV:10MG/M3 TDUST; 9293
Ingred Name:TONER CONTAINING INGRIENTS NUMBERS 7, 8, 9, AND 10
RTECS #:9999999ZZ
Other REC Limits:NONE SPECIFIED
Ingred Name:IRON OXIDE
CAS:1317-61-9
Other REC Limits:NONE SPECIFIED
OSHA PEL:10 MG/M3 TDUST
ACGIH TLV:5 MG FE/M3 FUME 9293
Ingred Name:STYRENE-ACRYLATE COPOLYMER
CAS:27136-15-8
Other REC Limits:NONE SPECIFIED
Ingred Name:ORGANIC PIGMENT, PMN NO.P-82-418
CAS:84179-66-8
Other REC Limits:NONE SPECIFIED
Ingred Name:AROMATIC METAL SALT, PMN NO. P-85-1368
CAS:42405-40-3
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MINIMUM IRRITATION TO RESPIRATORY
TRACT MAY OCCUR AS WITH EXPOSURE TO ANY NON-TOXIC DUST.
Effects of Overexposure:MINIMUM IRRITATION TO RESPIRATORY TRACT MAY
OCCUR AS WITH EXPOSURE TO ANY NON-T0XIC DUST.
Medical Cond Aggravated by Exposure:ACCUMULATION OF DUST IN THE
RESPIRATORY SYSTEM.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH LARGE AMOUNTS OF WATER. SKIN: WASH AREA WITH
SOAP AND WATER. INHALATION: MOVE TO FRESH AIR IF EFFECTS OCCUR. GET
MEDICAL ATTENTION. INGESTION: GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM, WATER.
Fire Fighting Procedures:THIS MATERIAL WILL BURN IN THE CASE OF FIRE.
Unusual Fire/Explosion Hazard:THIS MATERIAL HAS NO UNUSUAL FIRE OR
EXPLOSION HAZARDS.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP OR CLEAN UP WITH A VACUUM CLEANER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NO SPECIAL STORAGE REQUIREMENTS FOR
SAFETY REASONS.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED UNDER NORMAL USE.
Ventilation:NORMAL WORKPLACE VENTILATION IS ADEQUATE.
Other Protective Equipment:NONE REQUIRED UNDER NORMAL USE.
Work Hygienic Practices:INHALATION SHOULD BE AVOIDED. WASH AFTER
HANDLING AND BEFORE EATING, DRINKING, OR SMOKING.
Supplemental Safety and Health
KEY 1: N1, THIS ENTRY DESCRIBES PART B OF A 2 PART KIT. SEE THIS NSN PN
IND A FOR PART A DATA.
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:4.30 (H2O=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:FINE BLACK POWDER. ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
OXIDES OF NITROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE MATERIAL MAY BE DUMPED OR INCINERATED
UNDER CONDITIONS WHICH MEET ALL FEDERAL, STATE AND LOCAL
ENVIRONMENTAL REGULATIONS.
| 0 |
gloves_not_mandatory
|
=======================================================
Product ID: DEVELOPER FLUID CONTAINED IN POD OF FILM TYPE 108S
Cage: 0E411
=======================================================
Contractor Summary
=======================================================
Cage: 0E411
Cage: 29556
=======================================================
Ingredients
=======================================================
Cas: 1310-58-3
RTECS #: TT2100000
% Wt: 5-10
OSHA PEL: C 2 MG/M3
ACGIH TLV: C 2 MG/M3; 9495
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
------------------------------
Cas: 95-14-7
RTECS #: DM1225000
% Wt: 1-15
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 10551-21-0
% Wt: 1-5
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 10196-18-6
RTECS #: ZH4775000
% Wt: 0.1-1
OSHA PEL: 10 MG ZNO/M3
ACGIH TLV: 10 MG ZNO/M3; 9293
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE: EYE CONTACT WITH DEVELOPER MAY CAUSE PERMANENT EYE
DAMAGE. MAY CAUSE BURNS TO SKIN AND MOUTH. INHALATION: MAY BE AN IRRITANT.
EYES/SKIN/INGESTION: CORROSIVE. CHRONIC: NONE CURRENTLY KNOWN.
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDOUS.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: EYE:IMMED FLUSH EYES W/PLENTY OF H*2O FOR AT LEAST 15 MIN; SEEK MED
ATTN. SKIN:FLUSH AFFECTED AREA W/PLENTY OF H*2O. INHAL:IN CASE OF ORAL CNTCT
RINSE MOUTH IMMED W/PLENTY OF H*2O. DRINK H*2O/CITRUS J UICES TO DILUTE/NEUT
ANY ALKALI THAT MAY HAVE BEEN SWALLOWED. DO NOT INDUCE VOMIT. SEEK MED ATTN
IMMED. INGEST:SEEK MED ATTN IMMED. DO NOT INDUCE VOMIT. NOTES TO MD:PRLNGD
CNTCT W/SKIN MAY (SUPDAT)
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: HANDLE FILM SO AS NOT TO BREAK DEVELOPER PODS PRIOR
TO FILM DEVELOPMENT. SMALL QUANTITIES OF DEVELOPER FLUID MAY BE WIPED UP WITH
A DAMP PAPER TOWEL USING CARE TO AVOID ANY SKIN OR EYE CONTACT.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: PRODUCT (FILM PACK, PICTURE AND THROW AWAY PART) IS NOT
CLASSIFIED OR REGULATED UNDER FEDERAL, STATE AND LOCAL LAWS AS "RCRA
HAZARDOUS" BEFORE OR AFTER PROCESSING.
Handling And Storage Precautions: NOT AVAILABLE.
Other Precautions: DO NOT GET IN EYES, ON SKIN, MOUTH OR CLOTHING.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: TCC
Extinguishing Media: MEDIA SUITABLE FOR SURROUNDING FIRE (FP N).
Fire Fighting Procedures: USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: MIXTURE WILL NOT BURN.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NOT NORMALLY REQUIRED. NIOSH APPROVED RESPIRATOR
APPROPRIATE FOR EXPOSURE OF CONCERN (FP N).
Ventilation: NOT NORMALLY REQUIRED. PROCESSING OF LARGE QUANTITIES OF FILM
SHOULD BE HANDLED WITH LOCAL EXHAUST VENTILATION.
Other Protective Equipment: EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET ANSI
DESIGN CRITERIA (FP N).
Work Hygienic Practices: WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health: PH: >13 - DROPS RAPIDLY AFTER PROCESSING.
FIRST AID PROC: PRODUCE ALKALI BURNS. EYE PROT: AND FULL LENGTH FACESHIELD
(FP N).
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: 212F,100C
Spec Gravity: 1.1 (H*2O = 1)
PH: SUPDAT
Solubility in Water: @ 20C; DILUTABLE
Appearance and Odor: CREAM, WHITE, TAN, GREY OR PINK VISCOUS FLUID; NO ODOR.
Percent Volatiles by Volume: 85
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products: NONE SPECIFIED BY MANUFACTURER.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: DEVELOPER FLUID CONTAINED IN POD OF FILM TYPE 108S
Cage: 0E411
Company Name: POLAROID CORP
Street: 1265 MAIN ST
Zipcode: 02254-5000
Label Required IND: Y
Date Of Label Review: 09/23/1997
Status Code: C
Label Date: 09/23/1997
Origination
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Severe
Contact Hazard: Severe
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: CORROSIVE. ACUTE: EYE CONTACT WITH DEVELOPER MAY CAUSE
PERMANENT EYE DAMAGE. MAY CAUSE BURNS TO SKIN AND MOUTH. CHRONIC: NONE
CURRENTLY KNOWN.
=======================================================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:DEVCON HIGH HEAT REPAIR
CAGE:DO197
CAGE:16059
CAGE:DO197
============= Composition/Information on Ingredients =============
Ingred Name:GRAPHITE, NATURAL
CAS:7782-42-5
RTECS #:MD9659600
Fraction by Wt: 30-60%
Other REC Limits:2.5MG/M3 RESP DUST
OSHA PEL:15 MPPCF RDUST
ACGIH TLV:2 MG/M3 RDUST; 9293
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(RAT):1280MG/KG;DERMAL(SUP DAT)
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and
Chronic:ACUTE:EYES:IRRIATANT,SKIN:IRRITANT;INHALATION:NOT SUBJECT
TO INHALATION DUE TO VERY LOW VOLATILITY. CHRONIC DATA.NO DATA
Explanation of Carcinogenicity:N/A
Effects of Overexposure:SEE HEALTH HAZARDS SECTION
Medical Cond Aggravated by Exposure:N/K
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/ LGE AMTS OF WTR FOR AT LEAST 15MIN AND CONTACT
A PHYSICIAN. INGEST:ADMIN 2 GLASSES OF WTR N. INHAL:REMOVE TO FRESH
AIR. SUPPORT BREATHING (GIVE O*21ARTIFICAL RESPIRATION). SKIN:WAS H
W/ SOAP AND WATER.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:SCRAPE OR WIPE UP
Neutralizing Agent:N/K
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY PL.AVOID SKIN & EYE
CONT.IF CURED MATL SANDED OR MACH,USE PROPER PRECAUT.WEAR ADEQUATE
PROT EQPT TO PVNT OVEREXPOSURE TO (SUP DAT
Other Precautions:N/K
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE IN NORMAL USE. NIOSH/MSHA APPROVED
RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:NONE IN NORMAL USE. CONSULT LCL SAFETY/HEALTH AUTHORITIES
IF ADDITIONAL GUIDANCE IS NECESSARY .
Other Protective Equipment:N/K .
Work Hygienic Practices:N/K
Supplemental Safety and Health
LD50-LC0 MIX:LD50(RABBIT):NO DATA;INHAL LC50(RAT):NO DATA.RT OF
ENTRY:HDLG/STOR PRECAUTIONS:NVISANCE PARTICULATES.SM AMT OF GPH
DUST MAY BE GEN BY SANDING.GPH PWD HAS BEEN ISSUED A TLV-TWA OF
2.5M G/M3.
================== Physical/Chemical Properties ==================
Decomp Temp:Decomp Text:N/K
Vapor Pres:0
Spec Gravity:1.48
pH:8
Evaporation Rate & Reference:1 (BUCA=1)
Solubility in Water:APPRECIABLE
Appearance and Odor:GRAY PASTE, LOW ODOR
Percent Volatiles by Volume:0
Corrosion Rate:
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:N/K
Hazardous Decomposition Products:OXIDES OF CARBON, SILICON. AND SODIUM.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/ LOCAL, & STATE AND
FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
=======================================================
Product ID: STAY BLACK ASPHALT DRIVEWAY PATCHING MIX, 304
Cage: IO091
=======================================================
Contractor Summary
=======================================================
Cage: IO091
Cage: 11761
Box: 3001
=======================================================
Ingredients
=======================================================
% Wt: <1
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
Cas: 8052-42-4
RTECS #: CI9900000
% Wt: 5
OSHA PEL: N/K (FP N)
ACGIH TLV: 5 MG/M3; (FUME)
------------------------------
Cas: 8052-42-4
RTECS #: CI9900000
% Wt: <1
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: NO
Skin: NO
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE: REDDENING OF SKIN WITH MINOR IRRITATION. CHRONIC:
NONE LISTED BY MANUFACTURER.
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: NONE KNOWN.
First Aid: NONE. INGEST:CALL MD IMMEDIATELY (FP N). INHAL:REMOVE TO FRESH AIR.
SUPPORT BREATHING (GIVE O*2/ARTF RESP) (FP N). EYES:IMMEDIATELY FLUSH
W/POTABLE WATER FOR MINIMUM OF 15 MINUTES, SEEK ASSISTANCE FRO M MD (FP N).
SKIN:FLUSH W/COPIOUS AMOUNTS OF WATER. CALL MD (FP N).
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: SCOOP INTO CONTAINERS.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: SOLID WASTE DISPOSAL PER FEDERAL, STATE AND LOCAL
REGULATIONS.
Handling And Storage Precautions: ORDINARY.
Other Precautions: NONE.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: 200F,93C
Lower Limits: NONE
Extinguishing Media: FOAM, DRY CHEMICAL, BUT CARBON DIOXIDE IS PREFERRED.
Fire Fighting Procedures: NONE. USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: NONE.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NONE. NIOSH APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN (FP N).
Ventilation: ONLY TO PERMIT DRYING.
Other Protective Equipment: ANSI APPRVD EYE WASH & DELUGE SHOWER (FP N).
Work Hygienic Practices: WASH SKIN WITH SOAP AND WATER OR WATERLESS CLEANER.
Supplemental Safety and Health: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Physical/Chemical Properties
=======================================================
Vapor Density: NEGLIGIBLE
Evaporation Rate & Reference: SLOWER THAN ETHER
Solubility in Water: NOT KNOWN
Appearance and Odor: NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume: 20-30
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: EXTREME HEAT.
Materials To Avoid: STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products: SMOKE AND OXIDES OF CARBON.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
Other Information: MAXIUMUM VOLATILE ORGANIC COMPOUND: 0 GRAMS/LITER.
=======================================================
HAZCOM Label
=======================================================
Product ID: STAY BLACK ASPHALT DRIVEWAY PATCHING MIX, 304
Cage: IO091
Assigned IND: Y
Company Name: HENRY CO
Street: 5731 BICKETT ST
Zipcode: 90255
Label Required IND: Y
Date Of Label Review: 01/15/1998
Status Code: C
Label Date: 01/15/1998
Origination Code: G
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: None
Contact Hazard: Slight
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: ACUTE: REDDENING OF SKIN WITH MINOR IRRITATION.
CHRONIC: NONE LISTED BY MANUFACTURER.
=======================================================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:AD-BOND 1090 FOUNDRY BINDER
CAGE:ARSYS
CAGE:ARSYS
============= Composition/Information on Ingredients =============
Ingred Name:FURFURYL ALCOHOL
CAS:98-00-0
RTECS #:LU9100000
OSHA PEL:10 PPM;15 STEL, S
ACGIH TLV:10 PPM;15 STEL, S
Ingred Name:OLIGOMERS
Fraction by Wt: <2%
OSHA PEL:10 PPM
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: STRONG ODOR. HEADACHE.
IRRITATION OF EYES, SKIN, AND RESPIRATORY TRACT. CENTRAL NERVOUS
SYTEM DEPRESSION. CHRONIC: SKIN RASH. ALLERGIC REACTIONS. EXPOSURE:
DETECTABLE ODOR.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL: MOVE TO FRESH AIR. IF NECESSARY, RESTORE AND SUPPORT
BRTHG. EYES: IMMED FLUSH WITH WATER FOR AT LEAST 15 MINUTES WHILE
LIFTING LIDS AND ROLLING EYES. GET IMMED MED ATTN. SKIN: WASH
PROMPTLY W/S OAP & WATER. INGEST: GET MED HELP. IF CONSCIOUS AND
MED HELP IS NOT READILY AVAILABLE, GIVE WATER AND INDUCE VOMITING.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:171F,77C
Lower Limits:1.8%
Upper Limits:16.3%
Extinguishing Media:WATER SPRAY FOR DILUTION TO NON-FLAMMABLE MIXTURE.
DRY CHEMICAL, "ALCOHOL FOAM", CARBON DIOXIDE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . EVACUATE CONTAMD AREA. USE WATER SPRAY TO
COOL CONTRS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:ACID CONTAMINATION CAN CAUSE VIOLENT
EXOTHERMIC POLYMERIZATION. CLOSED CONTAINERS MAY EXPLODE OR RUPTURE
WHEN EXPOSED TO EXTREME HEAT(FIRE).
================== Accidental Release Measures ==================
Spill Release Procedures:PICK UP SPILL ON SAND, EARTH, OR OTHER NON-
COMBUSTIBLE, ABSORBENT MATERIAL. PLACE IN COVERED CONTAINER FOR
DISPOSAL. AVOID ACID CONTAMINATION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, VENTILATED AREA AWAY
FROM IGNITION SOURCES, ACIDS, AND FROM FOUNDRY CATALYSTS.
Other Precautions:AVOID ACID CONTAMINATION. NO SMOKING OR EATING IN
HANDLING AREA.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED ORGANIC VAPOR CANISTER MASK
WHERE TLV IS EXCEEDED.
Ventilation:LOCAL EXHAUST: REQUIRED.
Other Protective Equipment:EYE FOUNTAIN AND SAFETY SHOWER.
Work Hygienic Practices:AVOID DIRECT CONTACT WITH AD BOND 1090. DO NOT
WEAR CONTACT LENSES WHEN WORKING WITH THIS MATERIAL.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER. EYE PROT: LENGTH FACESHIELD .
================== Physical/Chemical Properties ==================
HCC:V4
Boiling Pt:B.P. Text:338F,170C
Melt/Freeze Pt:M.P/F.P Text:N/A(LIQUID)
Vapor Pres:5.5@55C
Vapor Density:3.4
Spec Gravity:1.15(H2O=1)
Solubility in Water:SOLUBLE
Appearance and Odor:AMBER LIQUID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS. CONTACT W/ACIDS CAN CAUSE VIOLENT ERUPTION &/OR EXPLOSIONS.
Stability Condition to Avoid:CONTACT W/ACIDS.
Hazardous Decomposition Products:COMBUSTION PRODUCES CARBON MONOXIDE
AND CARBON DIOXIDE.
Conditions to Avoid Polymerization:AVOID MIXING DIRECTLY
W/ACIDS/FOUNDRY CATALYSTS. BINDER/CATALYST MUST FIRST BE
DISTRIBUTED ON SAND.
==================== Disposal Considerations ====================
Waste Disposal Methods:(CONSULT FEDERAL, STATE AND LOCAL REGULATIONS).
DISPOSE OF AS AN IGNITABLE WASTE I/A/W REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:TEXO YARN
CAGE:47695
CAGE:9Y192
CAGE:47695
============= Composition/Information on Ingredients =============
Ingred Name:FIBROUS GLASS
CAS:65997-17-3
Fraction by Wt: >96%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 RDUST Z-3
ACGIH TLV:10 MG/M3(<7 MICRONS)
Ingred Name:SIZING
Fraction by Wt: <4%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: MAY CAUSE RESPIRATORY
IRRITATION IF DUST/FIBERS INHALED. MAY CAUSE MECHANICAL IRRITATION
ON CONTACT WITH SKIN AND EYES. CHRONIC: NONE SPECIFIED BY
MANUFACTURER.
Explanation of Carcinogenicity:CONINUOUS FILAMENT FIBERGLASS IS NOT
LISTED AS A CARCINOGEN BY IARC OR NTP.
Effects of Overexposure:RASH, ICHING, CONJUNCTIVITIS, COUGHING,
SNEEZING.
Medical Cond Aggravated by Exposure:NONE KNOWN
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH LOTS OF WATER WHILE HOLDING EYELIDS OPEN.
SEE DOCTOR IF SYMPTOMS PERSIST. SKIN: RINSE WITH LOTS OF WATER THEN
WASH WITH SOAP AND WATER. INHALED: REMOVE TO FRESH AIR. IF SYMPTOMS
DEVEL OP, SEE DOCTOR.
===================== Fire Fighting Measures =====================
Flash Point:NON FLAMMABLE
Extinguishing Media:MEDIA APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WAE SELF-CONTAINED BREATHING APPARATUS AND
BUNKER GEAR.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP OR MOP UP AND PLACE IN A CONTAINER
FOR LATER DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED. IF ENGINEERING CONTROLS
FAIL OR OTHER EMERGENCY CONDITIONS EXIST; USE NIOSH/MSHA APPROVED
RESPIRATOR WITH DUST CARTRIDGE. USE IN ACCORDANCE WITH 29 CFR
1910.134.
Ventilation:USE LOCAL EXHAUST TO MAINTAIN EXPOSURE LEVELS BELOW
REGULATORY LIMITS.
Other Protective Equipment:LONG SLEEVED SHIRTS, LONG PANTS
Work Hygienic Practices:WASH HANDS AFTER USE AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:1472F,800C
Spec Gravity:2.59
Solubility in Water:INSOLUBLE
Appearance and Odor:A TEXTURIZED PRODUCT CONSISTING OF YELLOW-WHITE TO
WHITE FIBERS, NO ODOR
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:NONE KNOWN
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:224G0903, PART 2, DEVRAN 224 BUILD EPOXY (SUPP DATA)
Kit Part:Y
CAGE:1HK86
CAGE:1HK86
============= Composition/Information on Ingredients =============
Ingred Name:ING 17:DURING WELDING & FLAME CUTTING ON SURFS COATED
W/THIS PROD. VAPS MAY SPREAD LONG DISTS. PVNT BUILD-UP BY (ING 19)
RTECS #:9999999ZZ
Ingred Name:ING 18:REMOVING HEAVY SOLVENT VAPORS FROM LOWER LEVELS OF
THE WORK AREA. ELIMINATE ALL IGNITION SOURCES.
RTECS #:9999999ZZ
Ingred Name:VENT:STDS IN MIXING, APPLICATION & CURING AREAS & TO REMOVE
SANDING DUSTS OF DRIED COATINGS & DECOMP PRODS (ING 18)
RTECS #:9999999ZZ
Ingred Name:SOLVENT NAPHTHA (PETROLEUM), LIGHT AROMATIC; (HIGH FLASH
AROMATIC NAPHTHA). VP:10. LD50:(ORAL,RAT) >5 GM/KG.
CAS:64742-95-6
RTECS #:WF3400000
Fraction by Wt: 15%
OSHA PEL:N/K
ACGIH TLV:100 PPM (MFR)
Ingred Name:TALC (POWDER), CONTAINING NO ASBESTOS FIBERS; (MAGNESIUM
SILICATE)
CAS:14807-96-6
RTECS #:WW2710000
Fraction by Wt: 20%
OSHA PEL:20 MPPCF
ACGIH TLV:2 MG/M3 RDUST
Ingred Name:PHENOLIC COMPOUND. VP:<2 @ 271F. LD50:(ORAL,RAT) 1.62 G/KG.
Fraction by Wt: 10%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:POLYAMIDE RESIN. VP:<1.
CAS:68071-65-8
Fraction by Wt: 20%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPDAT:(EVEN EMPTY) AS PROD/ITS RESIDUE MAY IGNITE. DURING
EMER CNDTNS OVEREXP TO DECOMP PRODS MAY CAUSE A HLTH (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8:HAZARD. SYMPTOMS MAY NOT BE IMMEDIATELY APPARENT.
OBTAIN MEDICAL ATTENTION.
RTECS #:9999999ZZ
Ingred Name:EFTS OF OVEREXP:BE HARMFUL/FATAL. WARNING! THIS PRODUCT
CONTAINS CHEM KNOWN TO THE STATE OF CALIFORNIA TO CAUSE CANCER.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC:INGEST:CONSULT MD IMMED. DO NOT INDUCE
VOMIT. ASPIR OF VOMITUS CAN CAUSE CHEM PNEUM WHICH CAN BE FATAL.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC:UNLABELLED CNTNRS. DO NOT REUSE EMPTY CNTNRS. IF
THIS MATL IS PART OF A 2 COMPONENT PROD, THEN MIXT (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12:OF BASE & CONVERTER PORTIONS WILL HAVE HAZARDS OF
BOTH COMPONENTS.
RTECS #:9999999ZZ
Ingred Name:RESP PROT:CHEM/MECH FILTER DESIGNED TO REMOVE COMBINATION
OF PARTICULATES & VAP. WHEN USED IN CONFINED AREAS, (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14:WEAR NIOSH APPRVD AIR SUPPLY RESP/USE HOODS. USE
NIOSH APPRVD RESP WHEN FLAME CUTTING, WELDING, BRAZING &(ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15:SANDING MATERIAL COATED W/THIS PRODUCT.
RTECS #:9999999ZZ
Ingred Name:SILICA, CRYSTALLINE - QUARTZ; (CRYSTALLINE SILICA)
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 20%
OSHA PEL:0.1 MG/M3 RDUST(MFR)
ACGIH TLV:0.1 MG/M3 RDUST
Ingred Name:BARIUM SULFATE
CAS:7727-43-7
RTECS #:CR0600000
Fraction by Wt: 10%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENTS.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL:IRRIT OF RESP TRACT; HDCH,
NAUS, DIZZ, WEAK & FATG. EXTREME EXPOS CAN RSLT IN UNCON & EVEN
RESP ARREST. SKIN/EYE CONT:CAUSES IRRIT. MAY BE HARMFUL IF ABSORBED
THRU SKIN. INGEST:CAN CAUSE S TOM &/OR INTEST IRRIT, NAUS, VOMIT &
DIARR. CHRONIC:RPTS HAVE ASSOC RPTD & PRLNG OCCUP OVEREXP TO (EFTS
OF OVEREXP)
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-QUARTZ:IARC
MONOGRAPHS, VOL 68, 1997:GRP 1. NTP 7TH ANNUAL RPT ON CARCINS,
1994:ANTIC TO BE CARCIN.
Effects of Overexposure:HLTH HAZ:SOLVS W/PERM BRAIN & NERV SYS DMG.
PRLNG/RPTD BRTHG OF SPRAY MIST &/OR SANDING DUST OVER PERIOD OF YRS
MAY CAUSE DUST DISEASE OF LUNGS. CONTAINS CRYSTALLINE SILICA WHICH
CAN CAUSE LUNG DMG & CANCER. RISK DEPENDS ON DURATION & LEVEL OF
EXPOS. NOTICE:INTENTIONAL MISUSE BY DELIB CONC & INHAL CONTENTS MAY
(ING 10)
Medical Cond Aggravated by Exposure:NONE, WHEN USED I/A/W SAFE HANDLING
& USE INFORMATION.
======================= First Aid Measures =======================
First Aid:INHAL:IF YOU EXPER DFCLTY IN BRTHG, LEAVE AREA TO OBTAIN
FRESH AIR. IF CONTINUED DFCLTY IS EXPERIENCED, SUMMON MED
ASSISTANCE IMMED. IF BRTHG CEASES, RESTORE USING APPRVD CPR
TECHNIQUES & SUMMON MED H ELP IMMED. EYES:FLUSH IMMED W/LG AMTS OF
WATER FOR AT LST 15 MINS. GET MED ASSISTANCE. SKIN:WASH AFFECTED
AREAS W/SOAP & WATER. REMOVE SOILED CLTHG. GET MED ASSISTANCE IF
IRRIT PERSISTS. (ING 11)
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:100F,38C
Lower Limits:1%
Extinguishing Media:IN CASE OF FIRE USE CO*2, DRY CHEMICAL, FOAM OR
OTHER NFPA APPROVED METHOD FOR TREATING A CLASS B FIRE.
Fire Fighting Procedures:USE NIOSH APPRVD SCBA & FULL PROT EQUIP .
SUMMON PROFESSIONAL FIREFIGHTERS. WATER SPRAY MAY BE INEFT. IF
WATER IS USED, FOG NOZZ PREF. IF EXPOS TO(SUPDAT)
Unusual Fire/Explosion Hazard:COMBUST LIQ-CLASS II. KEEP CNTNRS TIGHTLY
CLSD. ISOLATE FROM HEAT, ELEC EQUIP, SPKS & FLAME. DUE TO PRESS
BUILD-UP, CLSD CNTNRS EXPOS TO EXTREME HEAT (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNIT (FLAMES, HOT SURFS
& ELEC, STATIC/FRICTIONAL SPKS). PVNT BRTHG OF VAPS. VENT AREA.
BEFORE ATTEMPTING CLEAN-UP REFER TO HAZ CAUT INFO IN OTHER SECTIONS
OF THIS MSDS. CONTAIN SPILLED MATL & REMOVE W/INERT ABSORB
&(SUPDAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT BREATHE VAPS, SPRAY
MIST/SANDING DUST. DO NOT GET ON SKIN/IN EYES. KEEP AWAY FROM HEAT,
SPKS & FLAMES. DO NOT SMOKE. OBSERVE ALL APPLIC PRECS.
Other Precautions:PVNT BUILD-UP OF VAPS BY MAINTAINING CONTINUOUS FLOW
OF FRESH AIR. DO NOT STORE >120F/NEAR FIRE/OPEN FLAME. STORE LG
QTYS IN BLDGS TO COMPLY W/OSHA 1910.106. KEEP CNTNR CLSD WHEN NOT
IN USE. DO NOT TR ANSFER CONTENTS TO BOTTLES/OTHER(ING 12)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHEN SPRAY APPLIED IN OUTDOOR/OPEN AREAS &
DURING SANDING/GRINDING OPERATIONS, USE NIOSH APPRVD MECH FILTER
RESP TO REMOVE SOLID AIRBORNE PARTICLES OF OVERSPRAY & SANDING
DUST. WHEN USED IN RESTRICTED VENT AREAS, WEAR NIOSH APPRVD (ING
14)
Ventilation:PROVIDE GEN DILUTION/LOC EXHST VENT IN VOL & PATTERN TO
KEEP AIR CONTAM CONC BELOW CURRENT APPLIC SAFETY & HLTH (ING 17)
Other Protective Equipment:ANSI APPROVED EYE WASH FOUNTAIN & DELUGE
SHOWER . SOLVENT IMPERMEABLE CLTHG & BOOTS TO PREVENT SKIN CONT ARE
REC.
Work Hygienic Practices:REMOVE & WASH SOILED CLOTHING BEFORE REUSE.
WASH HANDS BEFORE EATING OR SMOKING.
Supplemental Safety and Health
MFR'S TRADE NAME/PART NO:COATING - NEUTRAL CONVERTER. FIRE FIGHT
PROC:FIRE/EXTREME HEAT, WATER SHOULD BE USED TO COOL CLSD CNTNRS &
PVNT PRESS BUILD UP/POSS AUTO-IGNIT. SPILL PROC:NON-SPARKING TOOLS.
STORE IN CLSD CNTNR UNTIL PROPERLY DISPOF. EXPLO HAZ:MAY EXPLODE.
NEVER USE WELDING/CUTTING TORCH ON/NEAR CNTNR (ING 8)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>306F,>152C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:1.45
VOC Pounds/Gallon:214
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:24.58
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT W/STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:MAY CAUSE TOXIC FUMES WHEN HEATED TO
DECOMPOSITION. FUMES MAY CONTAIN CARBON MONOXIDE, CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF I/A/W LOCAL, STATE & FEDERAL
REGULATIONS. INCINERATE ONLY IN APPROVED FACILITY. DO NOT
INCINERATE CLOSED CONTAINERS.
======================= Other Information =======================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:LITHIUM MANGANESE DIOXIDE BATTERY,BA-5372/U
Preparer's Name:PHILIP DIGENNARO
CAGE:0CEP0
Contract Num:DAAB07-99-C-A257
CAGE:0CEP0
============= Composition/Information on Ingredients =============
Ingred Name:LITHIUM METAL (LI)
CAS:7439-93-2
RTECS #:OJ5540000
Other REC Limits:NONE RECOMMENDED
Ingred Name:MANGANESE DIOXIDE (MNO2)
CAS:1313-13-9
RTECS #:OP0350000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG (MN)/M3 CEILING
ACGIH TLV:5 MG (MN)/M3 9293
Ingred Name:PROPYLENE CARBONATE (PC)
CAS:108-32-7
Other REC Limits:NONE RECOMMENDED
Ingred Name:DIMETHYOXY ETHER (DME)
Other REC Limits:NONE RECOMMENDED
Ingred Name:CARBON BLACK (C)
CAS:1333-86-4
RTECS #:FF5800000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3; 9293
Ingred Name:GRAPHITE, NATURAL (C)
CAS:7782-42-5
RTECS #:MD9659600
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15 MPPCF RDUST
ACGIH TLV:2 MG/M3 RDUST; 9293
Ingred Name:TEFLON (PTFE)
CAS:116-14-3
RTECS #:KX4025000
Other REC Limits:NONE RECOMMENDED
Ingred Name:LITHIUM TRIFLUOROMETHANE SULFONATE (LI CF 3508)
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL RAT LD50, NONE STATED.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PRODUCT IS NOT A HEALTH HAZARD UNDER
NORMAL CONDITIONS OF USE. RISK OF EXPOSURE OCCURS ONLY IF BATTERY
IS MECHANICALLY OR ELECTRICALLY ABUSED. PC IS MILD SKIN AND EYE
IRRITANT. DME IS SLIGHTLY TOXIC. AVOID ELECTROLYTE OR LITHIUM SKIN
AND EYE CONTACT. INHALATION OR INGESTION OF LITHIUM
TRIFLUOROMETHENE MAY BE HARMFUL.
Effects of Overexposure:ELECTROLYTE EXPOSURE TO SKIN AND EYES MAY CAUSE
IRRITATION AND IS SLIGHTLY TOXIC. INHALATION OR INGESTION OF
LITHIUM TRIFLUOROMETHENE SULFONATE MAY BE HARMFUL.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:NONE NORMALLY REQUIRED. HOWEVER, IF CONTACTED BY CORROSIVE
MATERIALS FROM LEAKING BATTERY: EYES: FLUSH WITH LARGE AMOUNTS OF
WATER. GET MEDICAL ATTENTION. SKIN: WASH AREA WITH SOAP AND WATER.
GET MEDI CAL ATTENTION. INHALATION: MOVE TO FRESH AIR. GET MEDICAL
ATTENTION. INGESTION: GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Extinguishing Media:LITH-X/METAL-X, SAND, DRY CHEMICAL.
Fire Fighting Procedures:RAPIDLY COOL BATTERIES WITH ABOVE
EXTINGUISHING MEDIA. DO NOT USE WATER. FOR LARGE NUMBER OF CELLS
INVOLVED IN FIRE, FIREMEN SHOULD USE SCBA.
Unusual Fire/Explosion Hazard:BATTERIES MAY EXPLODE, PYROLYZE, OR VENT
IF DISASSEMBLED, CRUSHED, RECHARGED OR EXPOSED TO FIRE OR HIGH
TEMPERATURE.
================== Accidental Release Measures ==================
Spill Release Procedures:IF CELL OR BATTERY VENTS, LEAKS OR IS
PUNCTURED, VENTILATE CONTAMINATED AREA. USE FULL PROTECTIVE
EQUIPMENT. REMOVE SPILLED LIQUID WITH ABSORBENT. AVOID SKIN AND EYE
CONTACT OR INHALATION OF VAPORS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT RECHARGE, DISASSEMBLE, HEAT
ABOVE 212F, INCINERATE OR EXPOSE CONTENTS TO WATER. DO NOT ALLOW
CELLS OR BATTERIES TO SHORT CIRCUIT.
Other Precautions:AVOID MECHANICAL OR ELECTRICAL ABUSE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED. USE SCBA FOR FIRES. IN
CASE OF SPILL USE A FULL FACE RESPIRATOR WITH PARTICULATE/ORGANIC
CARTRIDGE.
Ventilation:GOOD WORK AREA VENTILATION IS NORMALLY ADEQUATE. IN CASE OF
CELL VENTING PROVIDE AS MUCH VENTILATION AS POSSIBLE.
Other Protective Equipment:NONE NORMALLY REQUIRED.
Work Hygienic Practices:WASH AFTER HANDLING LEAKERS AND BEFORE EATING,
DRINKING, OR SMOKING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:V1
Boiling Pt:B.P. Text:DME 85C
Melt/Freeze Pt:M.P/F.P Text:DME -69C
Vapor Pres:DME 48
Vapor Density:DME 3.1
Spec Gravity:DME 0.868
Evaporation Rate & Reference:DME 4.99(BUTYL ACETATE=1)
Solubility in Water:DME:- COMPLETE
Appearance and Odor:SEALED BATTERY.INGRED:DME-COLORLESS LIQUID,SWEET
ODOR.LI-SOFT SILVERY METAL
Percent Volatiles by Volume:25
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
DO NOT EXPOSE VENTED CELLS TO WATER.
Stability Condition to Avoid:DO NOT HEAT, DISASSEMBLE OR RECHARGE. DO
NOT SHORT CIRCUIT OR INSTALL WITH INCORRECT POLARITY.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
Conditions to Avoid Polymerization:HAZARDOUS POLYMERIZATION WILL NOT
OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONSULT YOUR LOCAL ENVIRONMENTAL OFFICER.
DISPOSE OF WASTE IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Preparer's Name:DOD HMIS/DGSC-SSH
CAGE:JO772
CAGE:14153
CAGE:JO772
============= Composition/Information on Ingredients =============
Ingred Name:ASBESTOS, CHRYSOTILE
CAS:12001-29-5
RTECS #:CI6478500
OSHA PEL:0.2 FIBERS/CC
ACGIH TLV:2 FIBERS/CC; A1;9192
Ingred Name:ASBESTOS & STEEL OVERALL COMPOSITION
RTECS #:9999999ZZ
Ingred Name:GENERIC "MSDS". SPECIFIC ASBESTOS TYPE NOT KNOWN. ONE
CITED IS ASSUMED. INFORMATION BASED ON SEGMENT "M" OF "DLSC TIR"
RTECS #:9999999ZZ
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: NO ACUTE EFFECTS ARE KNOWN;
CHRONIC: DUST FROM ABRASIVE ACTIONS(EG. CUTTING, MACHINING,
FILING, ETC.) MAYCONTAIN ASBESTOS FIBERS. CHRONIC OVEREXPOSURE
TO AIRBORNE FIBERS MAY LEAD TO ASBESTOSIS & MESOTHELIOMA.
SMOKINGCOMBINED W/FIBER INHALATION GREATLY INCREASES LUNG
CANCER RISK!
Explanation of Carcinogenicity:OVEREXPOSURE TO AIRBORNE CONCENTRATIONS
OF ASBESTOS MAY LEAD TO ASBESTOSIS AND MESOTHELIOMA.
Effects of Overexposure:INHAL: INHALATION OF AIRBORNE DUST CONTAINING
ASBESTOS FIBERS ON REPEATED EXPOSURE MAY CAUSE OR CAN LEAD TO
ASBESTOSIS/ MESOTHELIOMA; SKIN: N/K; EYE: POTENTIAL IRRITATION
FROM AIRBORNE DUST; INGEST: N/K.
Medical Cond Aggravated by Exposure:RESPIRATORY DEFICIENCIES DUE TO
REPEATED INHALATION OF AIRBORNE FIBERS.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. OBTAIN MEDICAL ADVICE; SKIN:
WASH EXPOSED AREA WITH SOAP & WATER; EYE: FLOOD W/ WATER. IF
IRRITATION OCCURS, GET MEDICAL ATTN; INGEST: CONSULT A
PHYSICIAN; OTHER: CHANGE CLOTHING AS REQUIRED TO AVOIDCARRYING
DUST PARTICLES INTO OTHER AREAS
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:MATERIAL IS NOT FLAMMABLE ; USE MEDIA APPROPRIATE
FOR SURROUNDING FIRE.
Fire Fighting Procedures:COMBUSTION PRODUCTS OF THIS MATERIAL MAY BE
TOXIC. USE A SELF-CONTAINED BREATHING APPARATUS WHEN FIGHTING FIRES
INVOLVING CHEMICAL PRODUCTS.
Unusual Fire/Explosion Hazard:NONE KNOWN
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION. VACUUM OR WET
CLEAN IF DUST IS INVOLVED. ANY VACUUM SYSTEM SHOULD BE EQUIPPED W/
AN OUTLET "HEPA" FILTER TO PREVENT REINTRODUCING ASBESTOS FIBERS TO
THE ATMOSPHERE.
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLE IN A MATTER TO MINIMIZE
FORMATION OR RETENTION OF AIRBORNE DUST. USE PROPER PERSONAL
PROTECTION FOR TASK AT HAND. CHECK W/YOUR SAFETY OFFICE!!!
Other Precautions:AS MANUFACTURED, LOCKED-IN ASBESTOS DOES NOT PRESENT
A HAZARD. ONLY WHEN THE ITEM IS SUBJECTED TO ABRASIVE ACTIONS &
DUST IS GENERATED, THEN ASBESTOS FIBERS MAY BE RELEASED & BECOME
AIRBORNE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF EXPOSURES EXCEED ESTABLISHED LIMITS, A
NIOSH/MSHA APPROVED RESPIRATOR FOR ASBESTOS SHOULD BE USED.
CONSULT YOUR SAFETY OFFICE/IH PERSONNEL FOR GUIDANCE FOR THE TASK
AT HAND.
Ventilation:LOCAL EXHAUST IS RECOMMENDED IN SITUATIONS WHERE DUST IS
GENERATED BY ABRASIVE ACTIONS, ABRASION OR OTHER MEANS.
Other Protective Equipment:AS REQUIRED FOR TASK AT HAND, AND THE
GUIDANCE SET FORTH BY YOUR SAFETY OFFICE OR IH PERSONNEL
Work Hygienic Practices:DONOT INHALE DUST CREATED BY ABRADING ACTIONS.
USE FULL PROTECTION AGAINST AIRBORNE FIBERS. AVOID AIRBORNE DUST
CREATION
Supplemental Safety and Health
GENERIC "MSDS" CREATED FOR "NSN" IDENTIFIED BY "DISC" AS CONTAINING
ASBESTOS.WHEN A MANUFACTURER'S SPECIFIC "MSDS" IS PROVIDED FOR
MATERIAL PROCURED UNDER THIS NSN, THIS GENERIC "MSDS" WILL BE
REMOVED.
================== Physical/Chemical Properties ==================
HCC:T6
Evaporation Rate & Reference:NONE
Solubility in Water:NOT SOLUBLE
Appearance and Odor:MANUFACTURED COMMODITY DESCRIBED BY LOGISTICS:
"ITEM-NAME"
Percent Volatiles by Volume:NONE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:NONE KNOWN
==================== Disposal Considerations ====================
Waste Disposal Methods:DUST SHOULD BE HANDLED AS A HAZARDOUS AIR
POLLUTANT I/A/W 40CFR61 SUBPART "M" PERTAINING TO ASBESTOS. USE
LANDFILLS APPROVED FOR ASBESTOS DISPOSAL. NOTE IF ITEM UNDER
CONSIDERATION FOR DISPOSAL IS "FRIABLE OR NON-FRIABLE".
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:PROC BLUE QUICK SET
Preparer's Name:DICK KARBO
CAGE:KMADD
CAGE:KMADD
============= Composition/Information on Ingredients =============
Ingred Name:COPPER COMPOUND
Fraction by Wt: 15%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PROLONGED CONTACT W/SKIN/EYES CAN
CAUSE IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION
======================= First Aid Measures =======================
First Aid:EYES: FLUSH IMMEDIATELY W/WATER. SKIN: WASH AFFECTED AREA
W/SOAP & WATER. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:>200F
Extinguishing Media:FOAM, CO2, DRY CHEMICAL
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL: WIPE UP & STORE WIPERS IN UNDERWRITERS
APPROVED CONTAINERS. LARGE: SCOOP MATERIAL INTO SEALABLE
CONTAINERS. WIPE UP REMAINDER & STORE WIPERS IN UNDERWRITERS
APPROVED CONTAINERS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN CLOSED CONTAINERS.
Other Precautions:AVOID CONTACT W/SKIN, EYES & CLOTHING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AS REQUIRED
Ventilation:LOCAL EXHAUST
Work Hygienic Practices:WASH AFTER USE. REMOVE/LAUNDER CONTAMINATED
CLOTHING BEFORE REUSE. DON'T CONSUME FOOD/BEVERAGE WHERE PRODUCT IS
USED.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:470-610F
Evaporation Rate & Reference:SLOWER THAN WATER
Solubility in Water:INSOLUBLE
Appearance and Odor:OILY
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/FEDERAL, STATE &
LOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:BRAVO EXTRA HEAVY DUTY STRIPPER
CAGE:GO050
CAGE:0U826
CAGE:GO050
============= Composition/Information on Ingredients =============
Ingred Name:MONOETHANOLAMINE (LD50: 2050 MG/KG [ORAL,RAT])
CAS:141-43-5
RTECS #:KJ5775000
Fraction by Wt: 3-6%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:3 PPM; STEL 6 PPM
ACGIH TLV:3 PPM; STEL 6 PPM
Ingred Name:SODIUM SILICATE (LD50: 1300 - 2600 MG/KG [ORAL-RAT])
CAS:1344-09-8
Fraction by Wt: 3-6%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM HYDROXIDE (LD50: 140-340 MG/KG [ORAL-RAT]; LC50: >40
MG/M3/1 HR [INHALATION-RAT])
CAS:1310-73-2
RTECS #:WB4900000
Fraction by Wt: 3-5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:2 MG/M3 CEILING
ACGIH TLV:2 MG/M3 CEILING
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 75-90%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ACUTE ORAL EST LD50: >5000 MG/KG (RAT)
Health Hazards Acute and Chronic:EYES: CORROSIVE: MAY CAUSE PERMANENT
EYE DAMAGE. SKIN: CORROSIVE: MAY CAUSE CHEMICAL BURNS. INHALTION:
MAY CAUSE IRRITATION OF THE RESPIRATORY TRACT. INGESTION: CORROSIVE
TO MOUTH AND DIGESTIVE TRACT.
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
DISORDERS MAY BE MORE SUSCEPTIBLE TO IRRITATING EFFECTS.
======================= First Aid Measures =======================
First Aid:EYE CONTACT OCCURS, REMOVE CONTACT LENSES. FLUSH IMMEDIATELY
WITH WATER FOR 20 MIN. SEEK IMMEDIATE MEDICAL ATTENTION. GO TO
EMERGENCY ROOM BUT WASH EYE FIRST. SKIN: RINSE WITH PLENTY OF
WATER. IF IRRI TATION PERSISTS, GET MEDICAL ATTENTION.INHALATION:
REMOVE TO FRESH AIR. INGESTION: DON'T INDUCE VOMITING. DRINK 1-2
GLASSES WATER/MILK. NOTHING BY MOUTH TO UNCONSCIOUS PERSON. GET
IMMED MEDICAL AID.
===================== Fire Fighting Measures =====================
Extinguishing Media:FOAM, CO2, DRY CHEMICAL, WATER FOG
Fire Fighting Procedures:NORMAL FIRE FIGHTING PROCEDURES MAY BE USED.
COOL AND USE CAUTION WHEN APPROACHING OR HANDLING FIRE-EXPOSED
CONTAINERS.
Unusual Fire/Explosion Hazard:CORROSIVE MATERIAL
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB WITH OIL-DRI OR SIMILAR INERT MATERIAL.
SWEEP OR SCRAPE UP AND CONTAINERIZE. RINSE AFFECTED AREA THOROUGHLY
WITH WATER. WEAR/USE APPROPIATE PROTECTIVE EQUIPMENT.
======================Handling and Storage ======================
Handling and Storage Precautions:WARNING: CORROSIVE. CONTAINS CAUSTIC
ALKALI & MONOETHANOLAMINE. AVOID CONTACT. MAY BURN SKIN & DAMAGE
EYES. HARMFUL IF SWALLOWED. FOR INDUSTRIAL USE.
VENTILATION. WASH THOROUGHLY AFTER HANDLING. LAUNDER CONTAMINATED
CLOTHING/EQUIPMENT BEFORE REU SE. KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF MISTS/VAPORS ARE NOT ADEQUATELY CONTROLLED BY
LOCAL VENTILATION, USE APPROPRIATE RESPIRATORY PROTECTION TO
PREVENT OVEREXPOSURE.
Ventilation:GENRL ROOM VENT NORMALLY ADEQUATE.SUBSTANTIAL AMTS OF
MIST/VAPOR CAN BE CONTROLLD W/LOCAL EXHAUST VENT OR RESP PROTECTN.
Other Protective Equipment:IF MAJOR EXPOSURE IS POSSIBLE TO EYES/SKIN,
WEAR/USE APPROPRIATE PROTECTIVE EQUIPMENT.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Melt/Freeze Pt:M.P/F.P Text:32.0F,0.0C
Spec Gravity:1.1
pH:12.8MN
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, MILD CITRUS ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS (MURIATIC ACID). STRONG OXIDIZING MATERIALS (LIQUID
CHLORINE). AVOID CONTACT W/NON-FERROUS METAL
Stability Condition to Avoid:NONE KNOWN
Hazardous Decomposition Products:PRODUCES NORMAL PRODUCTS OF
COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL OF UNDILUTED PRODUCT IS REGULATED UNDER
ENVIRONMENTAL AND TRANSPORTATION LAWS AS A CORROSIVE WASTE.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:ALSEAL 585
CAGE:53012
CAGE:53012
============= Composition/Information on Ingredients =============
Ingred Name:ALUMINUM; (ALUMINUM POWDER) (SARA III)
CAS:7429-90-5
RTECS #:BD0330000
Fraction by Wt: 43.1%
OSHA PEL:15 MG/M3 DUST;5 FUME
ACGIH TLV:10 MG/M3 DUST;5 FUME
Ingred Name:PHOSPHATE/CHROMATE SOLUTION (1.9% TOTAL WT IS CRO3)
RTECS #:9999999ZZ
Fraction by Wt: 56.9%
Ingred Name:CHROMIUM (VI) OXIDE (1:3); (CHROMIC ACID) (SARA III)
CAS:1333-82-0
RTECS #:GB6650000
OSHA PEL:0.1 MG/M3 (CRO3), C
ACGIH TLV:0.05 MG/M3
Ingred Name:PHOSPHORIC ACID (SARA III)
CAS:7664-38-2
RTECS #:TB6300000
OSHA PEL:1 MG/M3;3 STEL
ACGIH TLV:1 MG/M3;3 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:FIRST AID PROC: BEFORE REUSE. DISCARD FOOTWEAR WHICH CANNOT
BE DECONTAMINATED. SEEK MED ATTN IF IRRIT DEVELOPS (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5: INHAL: REMOVE TO FRESH AIR. IF BRTHG IS DFCLT, HAVE
TRAINED PERSON ADMIN OXYGEN. IF RESP STOPS, GIVE (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6:MOUTH-TO-MOUTH RESUSCITATION. GET MED ATTENTION.
INGEST: NEVER GIVE ANYTHING BY MOUTH TO AN UNCON PERSON. (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7: IF SWALLOWED, DO NOT INDUCE VOMITING. GIVE LRG QTYS
OF WATER. IF AVAIL, GIVE SEVERAL GLASSES OF MILK. (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8: FOLLOW WITH MILK OF MAGNESIA. IF VOMITING OCCURS
SPONTANEOUSLY, KEEP AIRWAY CLEAR AND GIVE MORE WATER. (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9:SEEK MED ATTN IMMED. NOTE TO MD: MASSIVE OVEREXP TO
CHROMIC ACID COULD LEAD TO KIDNEY FAILURE AND DEATH (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10:DEATH HAS BEEN AVOIDED IN SEVERAL SUCH CASES THOUGH
THE USE OF EARLY RENAL DIALYSIS. IT HAS BEEN REPORTED(ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11:THAT THERE IS LITTLE VALUE FROM CHELATING AGENTS,
HOWEVER, ASCORBIC ACID ADMINISTERED INTRAVENOUSLY IS AN(ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12: EFTIVE ANTIDOTE IN PREVENTING RENAL FAILURE. SKIN
ULCERS MAY BE TREATED BY REMOVAL FROM EXPOSURE, DAILY (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13: CLEANING AND DEBRIDEMENT AND APPLICATION OIF
ANTIBIOTIC CREAM & DRESSING.
RTECS #:9999999ZZ
Ingred Name:WORK HYGIENE: BE AFFORDED AGAINST EXPOSURE TO SPRAY MIST.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:THAT OF CHROMIC ACID. ACUTE INHAL MAY
IRRIT & ULCERATE MEMRANES. CHRONIC INHHAL: AS A RESULT OF
PRLNGD/RPTD INHALATION OF MIST MAY CAUSE ULCERATION OF NASAL
SEPTUM. EPIDEMIOLOGICAL STUDIES INDICATE TH AT LONG TERM EXPOSURE
TO HIGH LEVELS OFMIST IS ASSOCIATED WITH INCREASES IN RESP TRACT
CANCER (EFTS OF OVEREXP)
Explanation of Carcinogenicity:CHROMIUM (VI) OXIDE (1:3): IARC
MONOGRAPH ON EVAL OF CARCIN RISK OF CHEMS TO MAN, VOL 49, PG 49,
1990: GRP 1.(SUPP DATA)
Effects of Overexposure:HLTH HAZ:IN MAN. THUS FAR, EPIDEMIOLOGICAL
STUDIES HAVE NOT DEMONSTRATED ANY INCREASED RISK OF LUNG CANCER AT
LEVELS BELOW THE CURRENT TLV FOR CRO3. ACUTE SKIN CNTCT MAY
REQUIRED MEDICAL ATTN. MAY CAU SE ULCERS ON SKIN. CHRONIC SKIN:
PRLNGD/RPTD SKIN CNTCT, ESPECIALLY W/BROKEN SKIN MAY CAUSE SEVERE
IRRIT, (SUPP DATA)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH MATL OUT IMMED THEN SEEK MED ATTN. IMMED FLUSH
EYES W/LRG AMTS OF WATER FOR @ LST 15 MIN FORCIBLY HOLDING APART TO
ENSURE COMPLETE IRRIGATION OF ALL EYE & LID TISSUE. WASHING EYES
WITHIN ON E MINUTE IS ESSENTIAL TO ACHEIVE MAX EFTIVENESS. SEEK MED
ATTN IMMED. SKIN: IMMED WASH CONTAM AREAS W/PLENTY OF SOAP & WATER
FOR @ LST 15 MIN. REMOVE CONTAM CLTHG & FOOTWEAR AND WASH CLTHG
(ING 5)
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:USE SAND OR CARBON DIOXIDE (CO2).
Fire Fighting Procedures:DO NOT USE EXTING AGENTS CONTAINING WATER AS
REACTION W/ALUMINUM MAY PRODUCE HYDROGEN GAS. WEAR NIOSH/MSHA
APPROVED SCBA & FULL PROT EQUIP .
Unusual Fire/Explosion Hazard:CONTACT WITH ALKALIS, STRONG REDUCING OR
OXIDIZING AGENTS MAY PRODUCE HYDROGEN GAS CAUSING FIRE OR EXPLOSION
HAZARD.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE NONESSENTIAL PERSONNEL. USE SAWDUST,
VERMICULITE, FULLER'S EARTH OR OTHER ABSORBENT MATERIAL TO SOAK UP
SPILL THEN NEUTRALIZE WITH SODIUM BICARBONATE. THEN FLUSH AREA WITH
WATER. DO NOT USE S TRONG ALKALIS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN AREA WHERE IT WIL NOT COME IN
CONTACT W/STRONG ALKALIS OR OXIDIZING AGENTS AS HYDROGEN GAS MAY BE
PRODUCED CAUSING FIRE OR EXPLOSION.
Other Precautions:PROTECT FROM FREEZING. AVOID CONTACT WITH SKIN &
EYES. EMPLOYEE EDUCATION AND TRAINING IN THE SAFE USE AND HANDLING
OF THIS PRODUCT ARE REQUIRED UNDER THE OSHA HAZ COMMUNICATION
STANDARD. DO NOT WEAR CONTACT LENSES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR WHEN
SPRAYING. #9910 RESPIRATOR MFG. BY 3M OR EQUIVALENT IS SUGGESTED.
OBSERVE OSHA REGULATIONS FOR RESPIRATOR USE (29 CFR 1910.134).
Ventilation:EXHAUST VENTILATION SUFFICIENT TO REMOVE SPRAY MIST.
Other Protective Equipment:ANSI APPROVED SAFETY SHWRS & EYEWASH STNS
SHOULD BE AVAILABLE. WEAR APRONS & CLOTHING W/MAX BODY COVERAGE.
Work Hygienic Practices:PRECS MUST BE TAKEN SO THAT PERSONS HNDLG THIS
PROD DO NOT BRTHE VAPS OR HAVE IT CNTCT THE EYES/SKIN. PROT MUST
(ING 15)
Supplemental Safety and Health
CARCIN COMMENTS: NTP 6TH ANNUAL REPORT ON CARCINS, 1991: KNOWN TO BE
CARCIN. EFTS OF OVEREXP: ULCERS & SORES. ACUTE EYE: IRRIT & CORR TO
EYES, MAY CAUSE BURNS/LOSS OF SIGHT. PERMANENT DMG WHILE UNCOMM ON
CAN OCCUR. CHRONIC EYE: PRLNGD/RPTD CNTCT MAY CAUSE CONJUNC. ACUTE
INGEST MAY RSLT IN SEVERE INJURY/DEATH.
================== Physical/Chemical Properties ==================
HCC:C1
Spec Gravity:1.59
pH:2.0
Solubility in Water:APPRECIABLE
Appearance and Odor:GREEN-GRAY WITH NO ODOR.
Percent Volatiles by Volume:63.7
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CONTACT WITH ALKALIS OR STRONG REDUCING OR OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:TOXIC PHOSPHIDE MAY BE GIVEN OFF IN
FIRE/ OTHER VERY HIGH TEMPERATURE CONDITIONS.
==================== Disposal Considerations ====================
Waste Disposal Methods:FILTER TO REMOVE ALUMINUM & DISCARD AS SOLID
CHEM WASTE. TREAT REMAINING LIQ W/SODIUM METABISULFITE, THEN
PRECIPITATE TRIVALENT CHROMIUM BY NEUTR W/ALKLI, SUCH AS LIME.
WASTE MUST BE DISPOSED OF IN AC CORDANCE W/FEDERAL, STATE, LOC
ENVIRON CTL REGS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:GARDFLEET MC 10W MIL-PRF-2104G
CAGE:3K676
Contract Num:SPO450-00-MC966
CAGE:3K676
============= Composition/Information on Ingredients =============
Ingred Name:HYDROTREATED PARAFFINIC DISTILLATES
Minumum % Wt:80.
Maxumum % Wt:90.
Ingred Name:PROPRIETARY ADDITIVES
Minumum % Wt:10.
Maxumum % Wt:20.
Ingred Name:ZINC SALTS OF DIALKYL DITHIOPHOSPHORIC ACID
(PHOSPHORODITHIOIC ACID, O,O-DI-C1-14-ALKYL ESTERS, ZINC SALTS)
CAS:68649-42-3
< Wt:5.
===================== Hazards Identification =====================
Health Hazards Acute and Chronic:EYE-THIS PRODUCT IS NOT NORMALLY
EXPECTED TO CAUSE EYE IRRITATION. SKIN-THIS PRODUCT IS NOT EXPECTED
TO CAUSE SKIN IRRITATION. INHALATION-CAUTION SHOULD BE TAKEN TO
PREVENT FORMING AEROSOL OR MISTINGOF THIS PRODUCT WITHOUT PROPER
RESPIRATORY PROTECTION. INGESTION-DO NOT INGEST. DUE TO THE
EXPECTED CONCENTRATION OF OIL (70-100%) INGESTION IS EXPECTED TO BE
RELATIVELY NON-TOXIC UNLESS LUNG ASPIRATI ON OCCURS. ASPIRATION MAY
LEAD TO CHEMICAL PNEUMONITIS WHICH IS CHARACTERIZED BY PULMONARY
EDEMA & HEMORRHAGE & MAY BE FATAL.
Explanation of Carcinogenicity:NOT DETERMINED.
Effects of Overexposure:EYE-AVOID PROLONGED OCNTACT WITH THE EYES WHICH
MAY CAUSE MILD EYE DISCOMFORT, TEARING, OR BLURRING OF VISION.
BASED ON DATA FROM SIMILAR MATERIALS. SKIN-PROLONGED OR REPEATED
CONTACT MAY LEAD TO AN A LLERGIC SKIN SENSITIZATION IN SOME
INDIVIDUALS & DERMATITIS (DRYNESS, CHAPPING & REDDENING OF SKIN).
BASED ON DATA FROM SIMILAR MATERIALS. INHALATION-OVEREXPOSURE BY
INHALATION OF HOT MATERIAL MAY CAU SE NONSPECIFIC DISCOMFORT, SUCH
AS NAUSEA, HEADACHE, OR WEAKNESS. INGESTION-SIGN OF LUNG
INVOLVEMENT INCLUDE INCREASED RESPIRATORY RATE, INCREASED HEART
RATE, BLUISH SKIN DISCOLORATION, COUGHING, CHOK ING & GAGGING.
======================= First Aid Measures =======================
First Aid:EYE-IMMEDIATELY FLUSH WITH LARGE AMOUNTS OF WATER & CONTINUE
FLUSHING UNTIL IRRITATION SUBSIDES. IF IRRITATION PERSISTS CALL A
DOCTOR. IF MATERIAL IS HOT, TREAT FOR THERMAL BURNS & TAKE VICTIM
TO HOSP ITAL. SKIN-REMOVE SOILED CLOTHES. WASH AREA WITH SOAP &
WATER. IF REDNESS/IRRITATION OCCURS, SEEK MEDICAL AID. IF MATERIAL
IS HOT, SUBMERGE AREA IN COLD WATER. IF SEVERELY BURNED, REMOVE TO
HOSPITAL IMMEDIATELY. INHALATION-ERMOVE TO FRESH AIR. USE OXYGEN
IF BREATHING IS DIFFICULT OR ARTIFICIAL RESPIRATION IF BREATHING
HAS STOPPED. SEEK MEDICAL AID. ORAL-DO NOT INDUCE VOMITING.
IMMEDIATELY GIVE 2GLASSES OF WATER. SEEK MEDICAL AID.
===================== Fire Fighting Measures =====================
Flash Point:=214.C, 417.2F
Extinguishing Media:USE DRY CHEMICAL, FOAM, WATER FOG OR CARBON
DIOXIDE.
Fire Fighting Procedures:WATER MAY BE INEFFECTIVE BUT CAN BE USED TO
COOL CONTAINERS EXPOSED TO HEAT OR FLAME. CAUTION SHOULD BE
EXERCISED WHEN USING WATER OR FOAM AS FROTHING AND SPLATTERING MAY
OCCUR, ESPECIALLY IF SPRAYED INTO CONTAINERS OF HOT BURNING
LIQUID.
Unusual Fire/Explosion Hazard:DENSE SMOKE MAY BE GENERATED WHILE
BURNING. TOXIC FUMES, GASES OR VAPORS MAY EVOLVE ON BURNING. HEAVY
FLAMMABLE VAPORS MAY SETTLE ALONG GROUND LEVEL AND LOW SPOTS TO
CREATE AN INVISABLE FIRE HAZARD. T HE VAPORS MAY EXTEND TO SOURCES
OF IGNITION AND FLASH BACK.
================== Accidental Release Measures ==================
Spill Release Procedures:IMMEDIATELY TURN OFF/ISOLATE ANY IGNITION
SOURCE. EVACAUTE AREA & VENTILATE. PERSONNEL WEARING PROPER
PROTECTIVE EQUIPMENT SHOULD CONTAIN SPILL IMMEDIATELY WITH INERT
MATERIAL BY FORMING DIKES. DIKES SHOULD BE PLACED TO CONTAIN SPILL
SO THAT AS TO PREVENT MATERIAL FROM ENTERING SEWERS & WATERWAYS.
LARGE SPILLS, MAY BE PICKED UP USING EXPLOSION PROOF, NON-SPARKING
VACUUM PUMPS, SHOVELS OR BUCKETS.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS CLOSED WHEN NOT IN
USE. DO NOT TRANSFER TO UNMARKED CONTAINERS. FIRE EXTINGUISHERS
SHOULD BE KEPT READILY AVAILABLE. EMPTY CONTAINERS RETAIN PRODUCT
RESIDUE WHICH MAY EXHIBIT HAZARDS O F MATERIALS, THEREFORE DO NOT
PRESSURIZE, CUT, GLAZE, WELD OR USE FOR ANY OTHER PURPOSES.
Other Precautions:RETURN DRUMS TO RECLAMATION CENTERS FOR PROPER
CLEANING & REUSE. STORE CONTAINERS AWAY FROM HEAT, SPARKS, OPEN
FLAMES, OR OXIDIZING MATERIALS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED IF AIRBORNE CONCENTRATIONS ARE
MAINTAINED BELOW THRESHOLD LIMITS LISTED ON PAGE 1. OTHERWISE A
RESPIRATORY PROTECTION PROGRAM MEETING OSHA 1910.134 AND ANSI Z88.2
REQUIREMENTS MUST BE FO LLOWED. WHERE MISTING MAY OCCUR, WEAR AN
MSHA/NIOSH APPROVED (OR EQUIVALENT) HALF-MASK FORM DUST/MIST AIR
PURIFYING RESPIRATOR.
Ventilation:USE ADEQUATE VENTILATION WHEN WORKING WITH MATERIAL IN AN
ENCLOSED AREA. MECHANICAL METHODS SUCH AS FUNE HOODS OR AREA FANS
MAY BE USED TO REDUCE VAPOR/MIST.
MAY BE USED.
Other Protective Equipment:APRON & OVERBOOTS OF CHEMICALLY IMPERVIOUS
MATERIALS SUCH AS NEOPRENE OR NITRILE RUBBER CAN BE WORN TO AVOID
ALLERGIC SKIN SENSITIZATION. IF HANDLING HOT MATERIAL USE INSULATED
PROTECTIVE EQUIPMENT.
Work Hygienic Practices:EYEWASH STATIONS & SHOWERS SHOULD BE AVAILABLE
IN AREAS WHERE THIS MATERIAL IS USED & STORED. CONSUMPTION OF FOOD
& DRINK SHOULD BE AVOIDED IN WORK AREAS WHERE PRODUCT IS PRESENT.
Supplemental Safety and Health
WASH SOILDED CLOTHING BEFORE RESUE. IF VAPOR OR MIST IS GENERATE WHEN
THE MATERIAL IS HEATED/HANDLED, ADEQUATE VENTILATION IN ACCORDANCE
WITH GOOD ENGINNERING PRACTICES MUST BE PROVIDED TO MAINTAIN CO
NCENTRATIONS BELOW THE SPECIFIED EXPOSURE. ALWAYS WASH HANDS/FACE
WITH SOAP 7 WATER BEFORE EATING, DRINKING, SMOKING.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:NOT DETERMINED
Vapor Pres:NEGLIGIBLE
Vapor Density:>1 AT STP
Spec Gravity:0.878 @ 15.6C
Viscosity:6.5 CST AT 100C
Evaporation Rate & Reference:NEGLIGIBLE AT STP
Solubility in Water:NEGLIGIBLE IN WATER
Appearance and Odor:MILD PETROLEUM HYDROCARBON ODOR. DARK BROWN, CLEAR
FLUID.
Percent Volatiles by Volume:NEGLIGIBLE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH ACIDS AND OXIDIZING MATERIALS.
Stability Condition to Avoid:AVOID HIGH TEMPERATURES AND PRODUCT
CONTAMINATION.
Hazardous Decomposition Products:SMOKE, CARBON MONOXIDE AND DIOXIDE, &
OTHER ALDEHYDES OF INCOMPLETE COMBUSTION. OXIDES OF C, ZN, CA, MG,
N, P & S. HYDROGEN SULFIDE & ALKLY MERCAPTANS & OTHER SULFIDES MAY
BE RELEASED.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
=================== Toxicological Information===================
Toxicological Information:INHALATION TOXICITY: ON RARE OCCASIONS,
PROLONGED & REPEATED EXPOSURE TO OIL MIST POSE A RISK OF PULMONARY
DISEASE SUCH AS CHRONIC LUNG INFLAMMATION. THIS CONDITION IS
USUALLY ASYMPTOMATIC AS A RESULT OF REPEATED SMALL ASPIRATIONS.
SHORTNESS OF BREATH & COUGH ARE MOST COMMON SYMPTOMS BASED ON DATA
FROM SIMILAR MATERIALS. DERMAL: PROLONGED/REPEATED CONTACT MAY MAKE
SKIN MORE SENSITIVE. MUTAGENICITY : CONTAINS ZINC ALKYL
DITHIOPHOSPHATES WHICH HAVE BEEN REPORTED TO HAVE WEAK MUTAGENIC
ACTIVITY IN CULTURED MAMMALIAN CELLS BUT NO EVIDENCE OF RISK TO
WORKERS AT PRODUCT CONCENTRATION.
===================== Ecological Information =====================
Ecological:ENVIRONMENTAL TOXICITY: MATERIAL MAY BE TOXIC TO AQUATIC
ORGANISIMS & SHOULD BE KEPT OUT OF SEWAGE & DRAINAGE SYSTEMS & ALL
BODIES OF WATER. ENVIRONMENTAL FATE: NO DATA AVAILABLE.
==================== Disposal Considerations ====================
Waste Disposal Methods:ALL DISPOSAL MUST COMPLY WITH FEDERAL, STATE &
LOCAL REGS. THE MATERIAL, IF SPILLED OR DISCARDED MAY BE A
REGULATED WASTE. REFER TO STATE & LOCAL REGS. DEPARTMENT OF
TRANSPORTATION REGS MAY APPLY FOR TRANSPORTING THIS MATERIAL WHEN
SPILLED. CAUTION-IF SPILLED MATERIAL IS CLEANED UP USING A
REGULATED SOLVENT, THE RESULTING MIX MAY BE REGULATED.
=================== MSDS Transport Information ===================
Transport Information:U.S. DOT BULK SHIPPING DESCRIPTION: DOES NOT
APPLY TO NON BULK OIL SHIPPING. U.S. DOT NON-BULK SHIPPING
DESCRIPTION: DOES NOT APPLY TO NON BULK OIL SHIPPING. U.S. DOT
IDENTIFICATION: NOT APPLICABLE. U .S. DOT HAZARD CLASSIFICATION:
NOT APPLICABLE.
===================== Regulatory Information =====================
SARA Title III Information:SECTION 302/304 EXTREMELY HAZARDOUS
SUBSTANCES: NONE. SECTION 311/312 HAZARD CATEGORIZATION: ACUTE
(IMMEDIATE HEALTH EFFECTS), SECTION 313 TOXIC CHEMICALS: ZINC:
<0.10%.
Federal Regulatory Information:PRODUCT IS CONSIDERED TO BE AN OIL UNDER
SECTION 311 OF CLEAN WATER ACT (40 CFR 110) & OIL POLLUTION CONTROL
ACT OF 1990. ANY SPILLS OR DISCHARGES THAT PRODUCE A VISIBLE SHEEN
OR FILM ON SURFACE OF WA TER MUST BE REPORTED TO NATIONAL RESPONSE
CENTER AT 800-424-8802. CERCLA: NOT DETERMINED. CONTACT LOCAL
AUTHORITIES.
State Regulatory Information:CALIFORNIA PROP 65: NOT APPLICABLE.
======================= Other Information =======================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:CHEM-CREST 200
CAGE:22221
CAGE:22221
============= Composition/Information on Ingredients =============
Ingred Name:ETHYLENE DIAMINE TETRA ACETIC ACID POTASSIUM SALT
Ingred Name:SODIUM CARBONATE
CAS:479-19-8
Ingred Name:BENZENESULFONIC ACID, DODECYL-, SODIUM SALT; (SODIUM
DODECYLBENZENE SULFONATE)
CAS:25155-30-0
RTECS #:DB6825000
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SILICIC ACID (H*2SIO*3), DISODIUM SALT; (SODIUM
METASILICATE, ANHYDROUS)
CAS:6834-92-0
RTECS #:VV9275000
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CAN IRRITATE &/OR BURN EYES & SKIN.
CAN DAMAGE RESPIRATORY & DIGESTIVE SYSTEMS. CAUSE COUGHING &/OR
UPSET STOMACH.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:BURNING OF EYES, SKIN, NASAL PASSAGES & THROAT.
Medical Cond Aggravated by Exposure:CAN AGGRAVATE EXISTING EYE, SKIN,
RESPIRATORY & DIGESTIVE CONDITIONS.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/LG AMTS OF WATER FOR @ LST 15 MINS, LIFTING
UPPER & LOWER LIDS OCCAS. SEE MD IMMED. SKIN:THORO WASH EXPOSED
AREA W/RUNNING WATER & SOAP. LAUNDER CLTHG BEFORE REUSE.
INGEST:GIVE TWO LG GLA SSES OF WATER, INDUCE VOMIT. SEE MD.
INHAL:REMOVE TO FRESH AIR. GIVE O*2 IF NECESSARY (ARTF RESP). SEE
MD.
===================== Fire Fighting Measures =====================
Flash Point:NO FLASH
Extinguishing Media:NO FIRE HAZARD. USE MEDIA SUITABLE FOR SURROUNDING
FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:SHOVEL UP, DISSOLVE IN WATER, SEWER. SOLUTION
SPILL:WASH DOWN DRAIN W/QUANTITY OF WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:WATER SOLUTIONS ARE GENERALLY SLIPPERY
& CARE SHOULD BE TAKEN WHEN WALKING ON FLOOR SPILL.
Other Precautions:KEEP CONTAINER CLOSED WHEN NOT IN USE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED DUST RESPIRATOR.
Ventilation:LOCAL EXHAUST/MECHANICAL (GENERAL) VENTILATION REQUIRED.
Other Protective Equipment:IMPERVIOUS CLTHG WHEN MAKING SOLUTION. EYE
BATH & SHOWER SHOULD BE AVAILABLE.
Work Hygienic Practices:AVOID SPLASHING OR SPILLING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:T6
Solubility in Water:COMPLETE
Appearance and Odor:WHITE POWDER BLEND; DETERGENT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:WATER SOLUTION IS BIODEGRADABLE. DISPOSAL MUST
BE I/A/W FEDERAL, STATE & LOCAL REGULATIONS .
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:E-904, ELMER'S NO WRINKLE RUBBER CEMENT
Resp. Party Other MSDS Num.:E904_B
CAGE:JO705
Contract Num:MDA414-01-P-0267
CAGE:09130
CAGE:JO705
============= Composition/Information on Ingredients =============
Ingred Name:ISOPROPANOL
CAS:67-63-0
RTECS #:NT8050000
Minumum % Wt:1.
Maxumum % Wt:5.
OSHA PEL:980 MG/M3;400 PPM
ACGIH TLV:983 MG/M3;400 PPM
ACGIH STEL:1230 MG/M3;500 PPM
Ingred Name:HEPTANE
CAS:142-82-5
RTECS #:MI7700000
> Wt:70.
OSHA PEL:2000 MG/M3;500 PPM
ACGIH TLV:1640 MG/M3;400 PPM
ACGIH STEL:2050 MG/M3;500 PPM
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE GIVEN FOR PRODUCT AS A WHOLE
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INGESTION: NOT EXPECTED TO BE HARMFUL
UNDER NORMAL CONDITIONS OF USE. IF ACCIDENTALY SWALLOWED, BURNS OR
IRRITATION TO MUCOUS MEMBRANES, ESOPHAGUS OR GI TRACT CAN RESULT.
INHALATION: MAY BE HARMFUL IF INHALED. LIQUID OR VAPOR MAY CAUSE
CENTRAL NERVOUS SYSTEM DEPRESSION. SKIN: MAY CAUSE IRRITATION ON
PROLONGED OR REPEATED SKIN CONTACT. EYES: CAUSES IRRITATION.
CHRONIC: ISOPROPANOL IS A SUSPECT REPR ODUCTIVE HAZARD. MAY CAUSE
REPRODUCTIVE DISORDERS BASED ON ANIMAL DATA. MAY CAUSE LIVER DAMAGE
BASED ON ANIMAL DATA. MAY CAUSE KIDENY DAMAGE BASED ON ANIMAL DATA.
Explanation of Carcinogenicity:AS OF THE DATE OF ISSUANCE OF THIS
DOCUMENT, THIS MATERIAL HAS NOT BEEN LISTED BY NTP, CLASSIFIED BY
IARC NOT REGULATED BY OSHA AS A CARCINOGEN.
Effects of Overexposure:ISOPROPANOL, 67-63-0: CAN CAUSE CENTRAL NERVOUS
SYSTEM DEPRESSION. SIGNS AND SYMPTOMS MAY INCLUDE HEADACHE,
DIZZINESS, NAUSEA, VOMITING, UNCONSCIOUSNESS AND EVEN ASPHYXIATION.
HEPTANE, 142-82-5: CAN C AUSE CENTRAL NERVOUS SYSTEM DEPRESSION.
SIGNS AND SYMPTOMS MAY INCLUDE HEADACHE, DIZZINESS, NAUSEA,
VOMITING, UNCONSCIOUSNESS AND EVEN ASPHYXIATION.
Medical Cond Aggravated by Exposure:NO DATA PROVIDED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGESTION: DILUTE BY DRINKING LARGE QUANTITIES OF WATER.
IMMEDIATELY CONTACT POISON CONTROL CENTER OR HOSPITAL EMERGENCY
ROOM FOR ANY OTHER ADDITIONAL TREATMENT DIRECTIONS. INHALATION:
REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE ARTIFICIAL
RESPIRATION, PREFERABLY MOUTH-TO-MOUTH. CALL A PHYSICIAN. SKIN:
FLUSH WITH WATER. EYES: IMMEDIATELY FLUSH WITH PLENTY OF WATER FOR
AT LEAST 15 MINUTES. EYELIDS SHOULD BE HELD APART DURING
IRRIGATION TO ENSURE WATER CONTACT WITH ENTIRE SURFACE OF EYES AND
LIDS. CALL A PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:=-4.C, 24.8F
Extinguishing Media:IN CASE OF FIRE, USE WATER SPRAY, DRY CHEMICAL,
FOAM OR CO2.
Fire Fighting Procedures:USE WATER TO KEEP FIRE-EXPOSED CONTAINERS
COOL.
Unusual Fire/Explosion Hazard:KEEP LIQUID AND VAPOR AWAY FROM HEAT,
SPARKS, FLAME AND OTHER IGNITION SOURCES. VAPOR IS HEAVIER THAN AIR
AND MAY SETTLE IN LOW PLACES OR TRAVEL OUTWARD TO A SOURCE OF
IGNITION AND FLASHBACK.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES. SOAK UP WITH
ABSORBENT MATERIAL AND REMOVE TO CHEMICAL DISPOSAL AREA. PREVENT
ENTRY INTO NATURAL BODIES OF WATER.
Neutralizing Agent:NO DATA PROVIDED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLE IN ACCORDANCE WITH GOOD
INDUSTRIAL HYGIENE AND SAFETY PRACTICES. THESE PRACTICES INCLUDE
AVOIDING UNECESSARY EXPOSURE AND REMOVAL OF OF THE MATERIAL FROM
EYES, SKIN AND CLOTHING. WASH THOROUGH LY AFTER HANDLING.
Other Precautions:AVOID BREATHING VAPOR. USE WITH ADEQUATE VENTILATION.
AVOID PROLONGED OR REPEATED CONTACT WITH SKIN AND CLOTHING. AVOID
CONTACT WITH EYES. STORE IN A COOL, DRY PLACE. KEEP CONTAINERS
TIGHTLY CLOSED. K EEP AWAY FROM HEAT, SPARKS, FLAME AND OTHER
IGNITION SOURCES. USE WITH ADEQUATE VENTILATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHERE AIR CONTAMINANTS EXCEED ACCEPTABLE
CRITERIA, USE NIOSH/MSHA APPROVED REPIRATORY PPROTECTIVE EQUIPMENT.
RESPIRATORS SHOULD BE SELECTED ON THE FOPM AND CONCENTRATION OF
CONTAMINANTS IN AIR IN ACCO RDANCE WITH OSHA LAWS AND REGULATIONS
OR OTHER APPLICABLE STANDARDS OR GUIDELINES, INCLUDING ANSI
STANDARDS REGARDING RESPIRATORY PROTECTION.
Ventilation:LOCAL EXHAUST, ENCLOSED SYSTEM DESIGN, PROCESS ISOLATION,
REMOTE CONTROL IN COMBINATION WITH PERSONAL PROTECTION.
CONTACT.
Other Protective Equipment:NO DATA PROVIDED BY MANUFACTURER.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
VENDOR PART NUMBER: 170-9944.
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:=90.C, 194.F
Vapor Pres:NOT AVAILABLE
Spec Gravity:0.71
pH:8 25 C
Evaporation Rate & Reference:>1
Solubility in Water:NEGLIBLE
Appearance and Odor:OPAQUE LIQUID
================= Stability and Reactivity Data =================
ACIDS, BASES, AMINES.
Stability Condition to Avoid:NORMALLY STABLE AS DEFINED IN NFPA 704-12
(4-2, 1). EXPOSURE TO HEAT, FLAME AND INCOMPATIBLES.
Hazardous Decomposition Products:CO, CO2.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
=================== Toxicological Information===================
Toxicological Information:ISOPROPANOL, CAS# 67-63-0, LC50: RAT: 16000
PPM/8H (SAX). LD50: ORL-RAT: 3.8 G/KG (MERK); SKN-RABBIT - 13 G/KG
(SAX). HEPTANE, CAS# 142-82-5: LC50: NOT AVAILABLE. LD50: NOT
AVAILABLE.
===================== Ecological Information =====================
Ecological:NOT DETERMINED,
==================== Disposal Considerations ====================
Waste Disposal Methods:RECOVER FREE LIQUID. ABSORB RESIDUE AND DISPOSE
OF ACCORDING TO LOCAT, STATE/PROVINCIAL, AND FEDERAL REQUIREMENTS.
EMPTY CONTAINER: MAY CONTAIN EXPLOSIVE VAPORS. DO NOT CUT, PUNCTURE
OR WELD ON OR NEA RBY.
=================== MSDS Transport Information ===================
Transport Information:THE DATA PROVIDED IN THIS SECTION IS FOR
INFORMATION ONLY AND MAY NOT BE SPECIFIC TO YOUR PACKAGE SIZE. YOU
WILL NEED TO APPLY THE APPROPRIATE REGULATIONS TO PROPERLY CLASSIFY
YOUR SHIPMENT FOR TRANS PORTATION. ORM-D CONSUMER COMMODITY.
===================== Regulatory Information =====================
SARA Title III Information:SARA TITLE III SECTION 311/312: FIRE HAZARD,
IMMEDIATE HEALTH HAZARD, DELAYED HEALTH HAZARD. SARA TITLE III
SECTION 313 AND 40 CFR PART 372: THIS PRODUCT CONTAINS THE
FOLLOWING TOXIC CHEMICAL(S) SUBJE CT TO THE REPORTING REQUIREMENTS
OF SECTION 313 OF TITLE III OF THE SUPERFUND AMENDMENTS AND
REAUTHORIZATION ACT OF 1986 AND SUBPART C-SUPPLIER NOTIFICATION
REQUIREMENT OF 40 CFR PART 372: NONE REQUI RED PER SARA TITLE III
SECTION 313.
Federal Regulatory Information:TSCA SECTION 8(B) INVENTORY: ALL
REPORTABLE CHEMICAL SUBSTANCES ARE LISTED ON THE TSCA INVENTORY. WE
RELY ON CERTIFICATIONS OF COMPLIANCE WITH OUR SUPPLIERS FOR
CHEMICAL SUBSTANCES NOT MANUFACTURERED BY BORDEN. OSHA HAZARD
COMMUNICATION STANDARD 29 CFR 1910.1200: THIS MATERIAL IS A "HEALTH
HAZARD" AND/OR A "PHYSICAL HAZARD" AS DETERMINED WHEN REVIEWED
ACCORDING TO THE REQUIREMENTS OF THE OSHA 29 C FR PART 1910.1200
"HAZARD COMMUNICATION STANDARD."
State Regulatory Information:NO DATA PROVIDED BY MANUFACTURER.
======================= Other Information =======================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:CUSTOM PLASMA STANDARD, PLHG4-2X
Preparer's Name:LINDA PINDILLI
CAGE:07977
CAGE:07977
============= Composition/Information on Ingredients =============
Ingred Name:NITRIC ACID (SARA III)
CAS:7697-37-2
RTECS #:QU5775000
Fraction by Wt: 1-50%
OSHA PEL:2 PPM/4 STEL
ACGIH TLV:2 PPM/4 STEL; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:MERCURIC NITRATE (SARA III)
CAS:10045-94-0
RTECS #:OW8225000
Fraction by Wt: 0-1%
OSHA PEL:0.1 MG HG/M3;SKIN;C
ACGIH TLV:0.1 MG HG/M3; 9192
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:SUPP DATA: COLOR. THE VAP & MIST MAY ERODE THE EXPSD TEETH
W/PRLNGD EXPOS. INGEST OF LIQ WILL CAUSE IMMED PAIN (ING 4)
RTECS #:9999999ZZ
Ingred Name:ING 3: AND BURNS OF MOUTH, ESOPHAGUS & GI TRACT. INHAL MAY
BE FATAL CAUSING SPASM, INFLAM & EDEMA OF LARYNX & (ING 5)
RTECS #:9999999ZZ
Ingred Name:ING 4: BRONCHI, CHEM PNEUM & PULM EDEMA. SYMP INCLUDE:
BURNING SENSATION, COUGHING, WHEEZING, LARYNGITIS, (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5: SHORTNESS OF BREATH, HEADACHE, NAUSEA AND VOMITING.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(ORAL,RAT) 51400 MG/KG FOR ING #2
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:THIS SOLN MAY BE HARMFUL IF INHALED,
INGESTED/CONT W/SKIN/EYES. ACUTE EXPOS TO MERCURY CAN CAUSE NAUS,
METALLIC TASTE, ABDOM PAIN, VOMIT, DIARR, HDCH, LOOSENED TEETH,
AND/OR ULCERS ON LIPS & CHEEKS. M USCULAR TREMORS & PSYCHIC
DISORDERS MAYACCOMPANY PREVIOUS SYMP FOLLOWING CHRONIC EXPOS. CONC
(SEE EFTS OF OVEREXPOSURE)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: NITRIC ACID MAY BE FATAL IF TOO MUCH
IS INHALED/ABSORBED THRU SKIN. CONC NITRIC ACID VAP/MIST IS AN
IRRITANT OF EYES, MUC MEMB & SKIN. IN CONT W/EYES, IT PRODUCES
SEVERE BURNS WHICH MAY RESU LT IN PERMANENT DMG & VISUAL
IMPAIRMENT. ON SKIN, THE LIQ/ CONC VAP PRODUCES IMMEDIATE, SEVERE &
PENETRATING (SUPP DATA)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR AT LEAST 15 MINUTES OCCASIONALLY
LIFTING UPPER & LOWER EYELIDS. SKIN: REMOVE CONTAMINATED CLOTHING,
THEN FLUSH WITH WATER FOR AT LEAST 15 MINUTES. WASH CLOTHING
THOROUGHLY B EFORE REUSE. INHAL: MOVE TO FRESH AIR. IF IRRITATION
CONTINUES, CALL MD IMMEDIATELY. INGEST: CALL MD IMMEDIATELY .
===================== Fire Fighting Measures =====================
Flash Point:NOT COMBUSTIBLE
Extinguishing Media:APPROPRIATE TO SURROUNDING FIRE CONDITIONS.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. CONC HNO3 REACTS EXPLO W/COMBUST ORG/READILY OXIDIZABLE MATLS
SUCH AS; ALCOHOL, WOOD, (SEE SUPP DATA)
Unusual Fire/Explosion Hazard:CONC HNO3 IS NOT COMBUST, BUT IS STRONG
OXIDIZER & ITS HEAT OF RXN W/REDUCING AGENTS/COMBUST MAY CAUSE
IGNIT. CAN REACT W/METALS TO RELEASE FLAM HYDROGEN GAS.
================== Accidental Release Measures ==================
Spill Release Procedures:VENT AREA. DILUTE SPILL W/WATER & NEUT W/ SODA
ASH, LIMESTONE, ETC. WIPE UP & PUT IN SEALED CNTNR FOR PROPER DISP.
WASH SPILL SITE OFF W/WATER AFTER MATL PICKUP IS COMPLETE. WEAR
RESP.
Neutralizing Agent:SEE SPILL/RELEASE PROCEDURES.
======================Handling and Storage ======================
Handling and Storage Precautions:CONCENTRATED NITRIC ACID WILL ATTACK
SOME FORMS OF PLASTICS, RUBBER, AND COATINGS. STORE AT ROOM
TEMPERATURE. KEEP TIGHTLY SEALED WHEN NOT IN USE.
Other Precautions:HAVE IMMEDIATE AVAILABILITY OF AN EYE WASH IN CASE OF
EMERGENCY. AVOID INHALATION, INGESTION AND CONTACT WITH EYES AND
SKIN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:CHEMICAL FUME HOOD.
Other Protective Equipment:EYE WASH IN CASE OF EMERGENCY. LAB COAT.
DELUGE SHOWER .
Work Hygienic Practices:WASH CAREFULLY AFTER USE.
Supplemental Safety and Health
FIRE FIGHT PROC: TURPENTINE, METAL POWDERS, HYDROGEN SULFIDE, ETC. MATL
TO AVOID: ALCOHOL, WOOD, TURPENTINE, METAL POWDERS, HYDROGEN
SULFIDE, ETC. CONTACT WITH STRONG BASES WILL CAUSE VIOLENT SPLATTER
ING. EFTS OF OVEREXP: BURNS; CONC SOLN CAUSE DEEP ULCERS & STAIN
SKIN A BRIGHT YELLOW/YELLOWISH BROWN (SEE ING 3)
================== Physical/Chemical Properties ==================
HCC:T6
Spec Gravity:APPROXIMATELY 1
Evaporation Rate & Reference:NOT AVAILABLE
Solubility in Water:SOLUBLE
Appearance and Odor:TRANSPARENT WITH AN ACRID ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CONC HNO3 IS A POWERFUL OXIDIZING AGENT. IT REACTS EXPLO W/COMBUST
ORG/READILY OXIDIZABLE MATLS SUCH AS; (SUPP DATA)
Stability Condition to Avoid:ELEVATED TEMPERATURES MAY CAUSE CONTAINERS
TO BURST AND LIBERATE TOXIC NOX.
Hazardous Decomposition Products:WILL RELEASE TOXIC NITROGEN OXIDE
FUMES AND VAPORS.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTACT LOCAL HAZARDOUS OR CHEMICAL WASTE
DISPOSAL AGENCY FOR REGULATIONS. DISPOSAL MUST BE IN ACCORDANCE
WITH FEDERAL, STATE AND LOCAL REGULATIONS .
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:TECHALLOY, 1561
CAGE:IO642
CAGE:IO642
CAGE:59711
============= Composition/Information on Ingredients =============
Ingred Name:ING 5:MAY DECREASE/INCR BY MANY TIMES THE ORIGINAL CONC IN
ELECTRODE. ALSO, NEW CMPNDS NOT IN ELECTRODE MAY FORM.(ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6:DECOMP PRODS OF NORMAL OPERATION INCL THOSE
ORIGINATING FROM VOLATILIZATION, REACTION, OR OXIDATION OF MATL(ING
8)
RTECS #:9999999ZZ
Ingred Name:ING 7:SHOWN IN ING SECTION, PLUS THOSE FROM THE BASE METAL
& COATING, ETC., AS NOTED ABOVE. REASONABLY EXPECTED (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8:FUME CONSTITUENTS OF PROD COULD INCL PRIMARY OXIDES
OF IRON;SECONDARY COMPLEX OXIDES OF MANGANSES, SILICON(ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9:& ALUMINUM. GASEOUS REACTION PRODS MAY INCL CARBON
MONOXIDE & CARBON DIOXIDE.OZONE & NITROGEN OXIDE MAY BE(ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10:FORMED BY RADIATION FROM ARC, IN ADDITION TO
SHIELDING GASES LIKE ARGON & CARBON DIOXIDE WHENEVER THEY (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11:ARE EMPLOYED. ONE REC WAY TO DETERMINE COMPOSITION &
QLTY OF FUMES & GASES TO WHICH WORKERS ARE EXPOSED (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12:IS TO TAKE AN AIR SAMPLE FROM INSIDE THE WELDER'S
HELMENT IF WORN OR IN WORKER'S BRTHG ZONE. SEE AWS F1. (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13:& AWS F1.2. SEE AWS PUBLICATION:"FUME AND GASES IN
THE WELDING ENVIRONMENT".
RTECS #:9999999ZZ
Ingred Name:OTHER PREC:CH. 9, SAFE PRATICES IN WELDING & CUTTING.
RTECS #:9999999ZZ
Ingred Name:W/FILTER EYE PROT:LENS. PROV PROT SCREENS & FLSH GOGGS, IF
NEC, TO SHLD OTRS. AS A RULE OF THUMB START W/SHADE (ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16:THAT IS TOO DARK TO SEE THE WELD ZONE. THEN GO THE
NEXT LIGHTER SHADE WHICH GIVES SUFFIENT VIEW OF THE WELD ZONE.
RTECS #:9999999ZZ
Ingred Name:IRON
CAS:7439-89-6
RTECS #:NO4565500
Fraction by Wt: 90-99%
OSHA PEL:10 MG/M3
ACGIH TLV:5 MG/M3
Ingred Name:MANGANESE (SARA III).
CAS:7439-96-5
RTECS #:OO9275000
Fraction by Wt: 1-5%
OSHA PEL:5 MG/M3 DUST, C
ACGIH TLV:5 MG/M3 DUST, 1 FUME
Ingred Name:SILICON
CAS:7440-21-3
RTECS #:VW0400000
Fraction by Wt: .1-1.0%
OSHA PEL:10 MG/M3 TDUST;5RESP
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:SUPP DATA:RESPECT TO THE FUME PLUME, AS WELL AS THE
PRESENCE OF CONTAMINANTS IN ATMOSPHERE (SUCH AS CHLORINATED (ING 5)
RTECS #:9999999ZZ
Ingred Name:ING 4:HYDROCARBON VAPS FROM CLEANING & DEGREASING
ACTIVITIES). WHEN ELECTRODE IS CONSUMED, FUME & GAS COMPONENT (ING
6)
RTECS #:9999999ZZ
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ELECTRIC ARC-WELDING MAY CREATE ONE OR
MORE OF THE FOLLOWING HLTH HAZ:FUMES & GASES CAN BE DANGEROUS TO
YOUR HEALTH. ARC RAYS CAN INJURE EYES & BURN SKIN. ELECTRIC SHOCK
CAN KILL. "SHORT-TERM OVEREXPO S TO WELDING FUMES MAY RESULT IN
DISCOMFORT SUCH AS: DIZZ, NAUS, OR DRYNESS OR IRRIT OF NOSE,
THROAT, (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:OR EYES, TIGHTNESS IN CHEST, FEVER AND
ALLERGIC REACTIONS, (SEE EXPLO HAZ AND SPILL/LEAK SECTION)."
"LONG-TERM (CHRONIC) OVEREXPOS TO WELDING FUMES MAY LEAD TO
SIDEROSIS (IRON DEPOSIT IN LUNG S) AND IS BELIEVED BY SOME
INVESTIGATORS TO AFFECT PULMONARY FUNCTION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH EYES WITH COPIOUS AMOUNTS OF WATER FOR AT LEAST 15
MINUTES . SKIN:FLUSH WITH COPIOUS AMOUNTS OF WATER . INHAL:REMOVE
TO FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTIFICIAL RESPIRA TION)
. INGEST:CALL MD IMMEDIATELY . EMPLOY FIRST AID TECHNIQUE
RECOMMENDED BY THE AMERICAN RED CROSS.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE EXTINGUISHING MEDIA SUITABLE FOR SURROUNDING
FIRES .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:WELDING ARC & SPARKS CAN IGNITE COMBUST &
FLAMMABLES. REFER TO AMERICAN NATIONAL STANDARDS Z49.1 FOR FIRE
PREVENTION DURING USE OF WELDING & ALLIED PROCEDURES.
================== Accidental Release Measures ==================
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:TRAIN THE WELDER NOT TO TOUCH LIVE
ELECTRICAL PARTS AND INSULATE HIMSELF FROM WORK AND GROUND. TRAIN
THE WELDER TO KEEP HIS HEAD OUT OF THE FUMES.
Other Precautions:USE EXHAUST SYS TO CLEAR WELDING FUMES.MAKE SURE
INHALED AIR DOES NOT CONTAIN FUME CONSTITUENTS ABOVE PERMISSIBLE
EXPOS LEVELS.FOR ADDN SAFETY INFO SEE AMER STD Z49.1-1983, SAFETY
IN WELDING & CUTTING , & WELDING HANDBOOK, VOL. 1, (ING 15)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE RESPIRABLE FUME RESPIRATORY OR AIR SUPPLIED
RESPIRATORY WHEN WELDING IN A CONFINED SPACE OR WHERE LOCAL EXHAUST
OR VENTILATION DOES NOT KEEP EXPOSURE BELOW THE RECOMMENDED
EXPOSURE LIMITS.
Ventilation:USE ENOUGH VENT, LOCAL EXHAUST AT ARC, OR BOTH, TO KEEP THE
FUMES AND GASES FORM THE WORKER'S BRTHG ZONE & GENERAL AREA.
Other Protective Equipment:ARM PROTECTORS, APRONS, HATS, SHOULDER
PROTECTION, AS WELL AS DARK SUBSTANTIAL CLOTHING.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
HAZ DECOMP PRODS:, & ELECTRODES USED. OTHER CNDTNS WHICH ALSO INFLUENCE
COMPOSITION & QUALITY OF FUMES & GASES TO WHICH WORKERS MAY BE
EXPOSED INCL:COATINGS ON METAL BEING WELDED (SUCH AS PAINT, PLATI
NG, OR GALVANIZING), NUMBER OF WELDERS & VOL OF WORK AREA, QUALITY
& AMT OF VENT, POSTION OF WELDER'S HEAD W/ (ING 3)
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:THE COMPOSITION & QUALITY OF WELDING
FUMES AND GASES ARE DEPENDED UPON THE METAL BEING WELDED, PROCESS,
PROC (SUPP DATA)
==================== Disposal Considerations ====================
Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT RESIDUE DISPOSABLE CONTAINER AND
OR LINER IN AN ENVIRONMENTALLY ACCEPTABLE MANNER, IN FULL
COMPLIANCE WITH FEDERAL, STATE, AND LOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:SCOTCHCAST BRAND ELECTRICAL RESIN 251, PART A (SEE SUPPL)
Kit Part:Y
Resp. Party Other MSDS Num.:10-2596-4
CAGE:75037
CAGE:31068
Contract Num:SP0430-99-M-TK42
CAGE:20200
CAGE:75037
============= Composition/Information on Ingredients =============
Ingred Name:TALC (CONTAINING ASBESTOS)
CAS:14807-96-6
RTECS #:MW2700000
Minumum % Wt:35.
Maxumum % Wt:45.
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.2 FIBERS/CC
ACGIH TLV:0.2 FIBERS/CC; 9394
Ingred Name:BISPHENOL A-EPICHLOROHYDRIN COPOLYMER
CAS:25068-38-6
RTECS #:CE6880000
Minumum % Wt:55.
Maxumum % Wt:65.
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
< Wt:1.
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:UNKNOWN IARC:YES
Health Hazards Acute and Chronic:TARGET ORGANS: N/P. EYES: MAY CAUSE
EYE IRRITATION. SKIN: ALLERGIC SKIN REACTION, MODERATE SKIN
IRRITATION. MAY BE ABSORBED THROUGH THE SKIN. INHALATION: ALLERGIC
RESPIRATORY REACTION, CENTRAL NERV OUS SYSTEM DEPRESSION,
IRRITATION OF THE UPPER RESPIRATORY TRACT.INGESTION: IRRITATION
OF GASTROINTESTINAL TISSUES.
Explanation of Carcinogenicity:CARBON BLACK (BENZENE SOLVENT EXTRACTS)
(1333-86-4) IS A POTENTIAL CANCER HAZARD CAUSING STOMACH & SKIN
CANCER BY THE DIETARY ROUTE OF EXPOSURE IN LABORATORY ANIMAL
STUDIES (IARC POSSIBLE HUMAN CARCIN OGEN 2B, CALIF. PROPOSITION
65).
Effects of Overexposure:SKIN: REDNESS, SWELLING, BLISTERING, & ITCHING.
DRYNESS. INHALATION: DIFFICULTY BREATHING, WHEEZING, TIGHTNESS OF
CHEST & RESPIRATORY FAILURE. HEADACHE, DIZZINESS, DROWSINESS,
DROWSINESS, INCOORDINA TION, SLOWED REACTION TIME, SLURRED SPEECH,
GIDDINESS & UNCONSCIOUSNESS. SORENESS OF THE NOSE & THROAT,
COUGHING & SNEEZING. INGESTION: PAIN, VOMITING, ABDOMINAL
TENDERNESS, NAUSEA, BLOOD IN VOMITUS, AND BLOOD IN FECES.
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH EYES WITH LARGE AMOUNTS OF WATER FOR
AT LEAST 15 MINUTES. GET IMMEDIATE MEDICAL ATTENTION. SKIN: FLUSH
SKIN WITH LARGE AMOUNTS OF WATER. IF IRRITATION PERSISTS, GET
MEDICAL AT TENTION. INHALATION: IF SIGNS/SYMPTOMS OCCUR, REMOVE
PERSON TO FRESH AIR, IF SIGNS/SYMPTOMS CONTINUE, CALL A PHYSICIAN.
INGESTION: DRINK TWO GLASSES OF WATER. CALL A PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:>148.9C, 300.F
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING, INCLUDING
HELMET, SELF-CONTAINED, POSITIVE PRESSURE OR PRESSURE DEMAND
BREATHING APPARATUS, BUNKER COAT AND PANTS, BANDS AROUND ARMS,
WAIST & LEGS, FACE MASK, & PROTECTI VE COVERING FOR EXPOSED AREAS
OF THE HEAD.
Unusual Fire/Explosion Hazard:NONE KNOWN.
================== Accidental Release Measures ==================
Spill Release Procedures:OBSERVE ALL PRECAUTIONS GIVEN. APPLY ABSORBENT
MATERIAL TO SPILL AREA. COLLECT AND PLACE IN CLOSABLE CONTAINER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP OUT OF THE REACH OF CHILDREN.
Other Precautions:DO NOT INGEST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SELECT ONE OF THE FOLLOWING NIOSH APPROVED
RESPIRATORS BASED ON AIRBORNE CONCENTRATIONS OF CONTAMINANTS & IN
ACCORDANCE WITH OSHA REGULATIONS: HALF-MASK ORGANIC VAPOR
RESPIRATOR.
Ventilation:USE WITH APPROPRIATE LOCAL EXHAUST VENTILATION. PROVIDE
APPROPRIATE LOCAL EXHAUST FOR HEAT CURING. USE RESPIRATORY
PROTECTION IF NEEDED.
Other Protective Equipment:USE ONE OR MORE OF THE FOLLOWING PERSONAL
PROTECTION ITEMS AS NECESSARY TO PREVENT SKIN CONTACT: APRON,
COVERALLS.
Supplemental Safety and Health
THIS MSDS IS FOR ONE PART OF A KIT (SCOTCHCAST BRAND ELECTRICAL RESIN
251). THE HMIS SERIAL NUMBERS FOR ALL PARTS OF THIS KIT
(INCLUDING THE ONE FOR THIS MSDS) ARE: CLFKZ & CLFLB.
================== Physical/Chemical Properties ==================
HCC:V5
Spec Gravity:1.48
Viscosity:100 POISE
Solubility in Water:NEG
Appearance and Odor:BUFF VISCOUS LIQUID, PUNGENT ODOR
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:CARBON MONOXIDE AND CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE IN AN INDUSTRIAL OR COMMERCIAL
FACILITY. DISPOSE OF COMPLETELY ABSORBED WASTE PRODUCT IN A
SANITARY LANDFILL. DISPOSE OF COMPLETELY CURED (OR POLYMERIZED)
MATERIAL IN A SANITARY LANDFILL.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:LEX-24 TRU-TEST SUPREME HI-Q ALL ACRYLIC LATEX ENAMEL
CAGE:TRUTE
CAGE:TRUTE
============= Composition/Information on Ingredients =============
Ingred Name:DIETHYLENE GLYCOL ETHYL ETHER, CARBITOL, CARBITOL
CELLOSOLVEETHOXY DIGLYCOL, 2-(2-ETHOXYETHOXY)-ETHANOL
CAS:111-90-0
RTECS #:KK8750000
Fraction by Wt: 1-5%
Ingred Name:VOL ORGANIC CMPD: <250 GM/L
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: IRRITATION OF EYES, NOSE,
THROAT, & MUCOUS MEMBRANES OF RESPIRATORY TRACT. SKIN/EYES:
IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: IRRITATION TO EYES, NOSE, THROAT, &
MUCOUS MEMBRANES OF RESPIRATORY TRACT. SKIN/EYES: IRRITATION.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. SKIN: WASH W/SOAP & WATER.
EYES: FLUSH IMMEDIATELY W/LARGE AMOUNTS OF WATER. INGESTION: GIVE 2
GLASSES OF WATER TO DILUTE. DON'T INDUCE VOMITING. OBTAIN MEDICAL
ATTENT ION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:FOAM, CO2, DRY CHEMICAL, WATER FOG
Fire Fighting Procedures:WATER MAY BE USED TO COOL CLOSED CONTAINERS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE OR BUILD-UP
PRESSURE WHEN EXPOSED TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:DIKE & CONTAIN SPILL W/INERT MATERIAL SUCH AS
SAND OR EARTH. TRANSFER THE LIQUID TO CONTAINERS FOR RECOVERY OR
DISPOSAL. KEEP SPILL OUT OF SEWERS & OPEN BODIES OF WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP FROM FREEZING. AVOID CONTACT
W/SKIN & EYES. DON'T TAKE INTERNALLY. AVOID INHALATION OF VAPORS OR
SPRAY MISTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHEN BRUSHED OR ROLLED NONE REQUIRED IF GOOD
VENTILATION MAINTAINED. DURING SPRAY APPLICATION, AN APPROVED
MECHANICAL FILTER RESPIRATOR TO REMOVE AIRBORN PARTICLES OF
OVERSPRAY IS REQUIRED.
Ventilation:SUFFICIENT TO KEEP <TLV.
Other Protective Equipment:EYE WASH FACILITY, PROTECTIVE CLOTHING
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH HANDS BEFORE EATING, SMOKING, OR USING WASHROOM.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F
Vapor Density:<AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:VARIES W/COLOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:EXTREME HEAT & FREEZING
==================== Disposal Considerations ====================
Waste Disposal Methods:LIQUID MATERIAL & CONTAMINATED DIKING MATERIAL
SHOULD BE LANDFILLED ACCORDING TO CURRENT LOCAL, STATE, & FEDERAL
REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:AMMONIA ABSORBER
CAGE:4S984
CAGE:4S984
============= Composition/Information on Ingredients =============
Ingred Name:CITRIC ACID
CAS:77-92-9
RTECS #:GE7350000
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Explanation of Carcinogenicity:NONE
======================= First Aid Measures =======================
First Aid:SKIN/EYES: FLUSH W/WATER.
================== Accidental Release Measures ==================
Spill Release Procedures:COVER W/SODA ASH OR SODIUM BICARBONATE TO
NEUTRALIZE. WASH W/WATER INTO APPROVED SEWER OR CONTAINER.
Neutralizing Agent:SODA ASH OR SODIUM BICARBONATE.
======================Handling and Storage ======================
Other Precautions:AVOID CONTACT W/EYES & SKIN.
============= Exposure Controls/Personal Protection =============
Ventilation:GOOD
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:219F
Vapor Pres:16
Vapor Density:.62
Spec Gravity:1.24
Evaporation Rate & Reference:(BU AC = 1): <1
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR WHITE TO MEDIUM YELLOW LIQUID, ODORLESS TO
SLIGHT SUGAR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:XCI 8R7602 BINDER TAPE
CAGE:26921
CAGE:26921
============= Composition/Information on Ingredients =============
Ingred Name:DIMER FATTY ACID, ETHYLENEDIAMINE, PIPERAZINE AZELAIC ACID
POLYMER
CAS:68139-70-8
Ingred Name:C36 FATTY ACID DIMER, AZELAIC ACID, ETHYLENEDIAMINE, C36
DIMER DIAMINE POLYMER
CAS:69012-93-7
Ingred Name:ETHYLENE-VINYL ACETATE COPOLYMER
(ACETIC ACID ETHENYL ESTER, POLYMER W/ETHENE) *95-1*
CAS:24937-78-8
Ingred Name:ROSIN ACID *95-1*
CAS:8050-09-7
Ingred Name:PARAFFIN WAX FUME, PARAFFIN
CAS:8002-74-2
RTECS #:RV0350000
ACGIH TLV:2 MG/CUM
Ingred Name:ACRYLONITRILE (SUSPECTED HUMAN CARCINOGEN BY ACGIH & IARC,
CONFIRMED ANIMAL CARCINOGEN BY IARC GROUP 2A) *95-1*
CAS:107-13-1
RTECS #:AT5250000
OSHA PEL:2 PPM
ACGIH TLV:4.3 MG/CUM (A2)
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:CELLULOSE
CAS:9004-34-6
RTECS #:FJ5691460
OSHA PEL:5 MG/CUM
ACGIH TLV:10 MG/CUM (DUST)
Ingred Name:ALUMINUM (POWDER) *95-1*
CAS:7429-90-5
RTECS #:BD0330000
Fraction by Wt: 5-10%
OSHA PEL:15 MG/CUM
ACGIH TLV:10 MG/CUM (DUST)
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EYES: MILD IRRITATION. SKIN: MILD
IRRITATION. MOLTEN ADHESIVE MAY CAUSE SEVERE BURNS.
Explanation of Carcinogenicity:SEE INGREDIENTS
Effects of Overexposure:IRRITATION & BURNS.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER. SKIN: WASH W/SOAP & WATER. IMMEDIATELY
COOL W/COLD WATER IF CONTACT W/MOLTEN ADHESIVE. INHALATION: REMOVE
TO FRESH AIR. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER, FOAM, CO2, DRY CHEMICAL.
Fire Fighting Procedures:FOR LARGE QUANTITIES INVOLVED IN A FIRE, USE
SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:CONSTITUENTS OF THIS MATERIAL ARE
COMBUSTIBLE.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED WHEN USED AS INTENDED.
Other Protective Equipment:NONE REQUIRED WHEN USED AS INTENDED
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Solubility in Water:NEGLIGIBLE
Appearance and Odor:ADHESIVE BINDER W/MINIMAL ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:OPEN FLAME & HIGH ELECTRIC ARC.
Hazardous Decomposition Products:CO, CO2 & OTHER TOXIC PRODUCTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 0 |
gloves_not_mandatory
|
===================== Product Identification =====================
Product ID:MAP-9244 LITHIUM THIONYL CHLORIDE BATTERY
Preparer's Name:DGSC-VBA STAFF
CAGE:0B3X4
CAGE:0B3X4
CAGE:81855
============= Composition/Information on Ingredients =============
Ingred Name:THIONYL CHLORIDE
CAS:7719-09-7
RTECS #:XM5150000
Other REC Limits:NONE SPECIFIED
OSHA PEL:C 1 PPM
ACGIH TLV:C 1 PPM; 9394
Ingred Name:LITHIUM METAL
CAS:7439-93-2
RTECS #:OJ5540000
Other REC Limits:NONE SPECIFIED
Ingred Name:LITHIUM CHLORIDE
CAS:7447-41-8
RTECS #:OJ5950000
Other REC Limits:NONE RECOMMENDED
Ingred Name:ALUMINUM CHLORIDE
CAS:7446-70-0
RTECS #:BD0525000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PRODUCT PRESENTS HEALTH HAZARD ONLY IF
SEALED CASE IS BREACHED. VAPORS FROM LEAKING ELECTROLYTE ARE
IRRITATING. ELECTROLYTE IS CORROSIVE TO SKIN & EYES. EXPLOSION AND
THE ACCOMPANYING PHYSICAL TRAUMA ARE PROBABLY MORE LIKELY THAN
CONTACT WITH THE INTERNALS.
Explanation of Carcinogenicity:NO INGREDIENT OF A CONCENTRATION OF 0.1%
OR GREATER IS LISTED AS A CARCINOGEN OR SUSPECTED CARCINOGEN.
Effects of Overexposure:EYES:TEARING,BURNING,SEVERE IRRITATION,
CORROSION. SKIN:SEVERE IRRITATION,BURNS.INHALED:BURNING,CHOKING.
Medical Cond Aggravated by Exposure:NONE REPORTED. HMIS:EXPECT
RESPIRATORY PROBLEMS TO BE AGGRAVATED BY BREATHING VAPORS FROM
LEAKING BATTERIES.
======================= First Aid Measures =======================
First Aid:INHALATION-REMOVE TO FRESH AIR. GIVE MOUTH-TO-MOUTH
RESUSCITATION IF NOT BREATHING. GET MEDICAL ATTENTION IMMEDIATELY.
EYE-IMMEDIATELY FLUSH WITH RUNNING WATER FOR 15 MINUTES, LIFTING
LIDS. GET MEDICA L ATTENTION IMMEDIATELY. SKIN-WASH WITHSOAP &
WATER. REMOVE CONTAMINATED CLOTHING. INGESTION-DO NOT INDUCE
VOMITING. NOTHING BY MOUTH IF UNCONSCIOUS. GET MEDICAL ATTENTION
IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:LITH-X,PYRENE G-1,GRAPHITE,DRY LITHIUM CHLORIDE. DO
NOT USE WATER,MOIST SAND,CARBON DIOXIDE.
Fire Fighting Procedures:DO NOT USE WATER. WEAR SELF CONTAINED
BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:MAY EXPLODE IF EXPOSED TO HIGH
TEMPERATURES.
================== Accidental Release Measures ==================
Spill Release Procedures:DO NOT DISCARD. WEAR PROPER PROTECTIVE
CLOTHING IF LEAKING. PLACE IN A CONTAINER FOR LATER DISPOSAL.
Neutralizing Agent:SODIUM BICARBONATE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN REFRIGERATED AREA APPROPRIATE
FOR LITHIUM BATTERIES.
Other Precautions:NONE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF ENGINEERING CONTROLS FAIL OR NON-ROUTINE USE
OR EMERGENCY OCCURS; USE NIOSH/MSHA APPROVED RESPIRATOR OR SUPPLIED
AIR RESPIRATOR OR SCBA, AS REQUIRED. USE IAW 29 CFR 1910.134 AND
MANUFACTURER'S RECO MMENDATIONS.
Ventilation:USE LOCAL EXHAUST TO REMOVE FUMES FROM LEAKING BATTERIES.
Other Protective Equipment:EYE WASH STATION & SAFETY SHOWER AVAILABLE
FOR EMERGENCIES.
Work Hygienic Practices:USE VERY STRICT CHEMICAL HYGIENE PRACTICE WHEN
HANDLING LEAKING BATTERY. AVOID ALL CONTACT.
Supplemental Safety and Health
MSDS GENERATED BY DLA-HMIS STAFF. MFR GAVE MSDS FOR EACH INGREDIENT,
NOT THE BATTERY AS A WHOLE. THIS MSDS REPRESENTS BATTERY AS A
WHOLE. SEE PNI B,C,D,E FOR MSDS THAT MFR SENT.
================== Physical/Chemical Properties ==================
HCC:Z6
Appearance and Odor:3.5 VOLT HERMETICALLY SEALED BATTERY, 4 X 6.6 X 1.5
INCHES. FOR F-15A/B/C/D/E.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED.
Stability Condition to Avoid:TEMPERATURES OVER 160F/71C. HUMID (MOIST)
STORAGE CONDITIONS.
Hazardous Decomposition Products:SULFUR OXIDES OR CHLORIDES, HYDROGEN
CHLORIDE, LITHIUM OXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:RETURN TO DEFENCE PROPERTY DISPOSAL. DO NOT
DISCARD, INCINERATE, SHORT CIRCUIT OR RECHARGE.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:METHYLPREDNISOLONE SODIUM SUCCINATE
CAGE:GO395
CAGE:GO395
CAGE:60567
============= Composition/Information on Ingredients =============
Ingred Name:METHYLPREDNISOLONE SODIUM SUCCINATE *95-1*
CAS:2375-03-3
RTECS #:TU4154060
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE, SKIN &/RESPIRATORY TRACT
IRRITATION. POSSIBLE HYPERSENSITIZATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYE, SKIN, &/RESPIRATORY TRACT IRRITATION.
POSSIBLE HYPERSENSITIZATION.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. INGESTION: FLUSH MOUTH OUT
W/WATER. SKIN: FLUSH AREA W/WATER. EYES: FLUSH W/WATER. OBTAIN
MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER SPRAY, DRY CHEMICAL, CO2, FOAM AS APPROPRIATE
FOR SURROUNDING FIRE & MATERIALS.
Fire Fighting Procedures:USE SCBA & PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:DRY POWDER MATERIAL IS ASSUMED TO BE
COMBUSTIBLE.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PERSONAL PROTECTIVE EQUIPMENT. VACUUM W/A
VACUUM CLEANER HAVING A HIGH EFFICIENCY PARTICULATE (HEPA) FILTER.
ABSORB LIQUID W/PAPER TOWELS. WIPE WORKING SURFACES TO DRYNESS,
WASH W/SOAP & WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:GROUND MECHANICAL EQUIPMENT IN CONTACT
W/DRY MATERIAL TO DISSIPATE BUILDUP OF STATIC ELECTRICITY.
Other Precautions:AVOID ALL CONTACT & INHALATION OF DUST, FUMES, MISTS,
&/VAPORS ASSOCIATED W/THE PRODUCT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED RESPIRATOR.
Ventilation:LOCAL EXHAUST
Other Protective Equipment:DISPOSABLE PROTECTIVE APPAREL
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Solubility in Water:COMPLETE
Appearance and Odor:WHITE TO NEARLY WHITE LYOPHILIZED POWDER W/NO ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:FREEZING
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE SHOULD BE DISPOSED OF IAW/FEDERAL, STATE &
LOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:NITRIC ACID, A200-612GL
CAGE:1B464
CAGE:1B464
============= Composition/Information on Ingredients =============
Ingred Name:NITRIC ACID (SARA 302/313) (CERCLA)
CAS:7697-37-2
RTECS #:QU5775000
Fraction by Wt: 69-71%
OSHA PEL:2 PPM
ACGIH TLV:2 PPM/4 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:WATER LD50 (ORAL RAT): 90 ML/KG
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 29-31%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENT 2.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS: NONE. ACUTE: EYE: SEV
EYE BURNS. MAY CAUSE IRREVERSIBLE EYE INJURY. SKIN: MAY CAUSE SEV
IRRIT. CAUSES SKIN BURNS. MAY CAUSE DEEP, PENETRATING ULCERS OF
SKIN. INGEST: GI TRACT BURNS. MAY CAUSE PERFORATION OF DIGESTIVE
TRACT. INHAL: MAY BE FATAL IF INHALED. EFTS MAY BE DELAYED. MAY
CAUSE (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: IRRIT OF RESP TRACT W/BURNING PAIN IN
NOSE & THROAT, COUGHING, WHEEZING, SHORTNESS OF BRTH & PULM EDEMA.
CHRONIC: RPTD INHAL MAY CAUSE CHRONIC BRONCHITIS. REPEATED EXPOSURE
MAY CAUSE EROSION OF TEETH.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MIN, OCCAS
LIFTING UPPER & LOWER LIDS. GET MED AID IMMED. DO NOT ALLOW VICTIM
TO RUB/KEEP EYES CLSD. SKIN: FLUSH W/PLENTY OF SOAP & WATER FOR AT
LEAST 15 MIN WHILE REMOVING CONTAM CLTHG & SHOES. GET MED AID IF
IRRIT DEVELOPS/PERSISTS. WASH CLTHG BEFORE REUSE. INGEST: DO NOT
INDUCE VOMIT & SEEK IMMED MED ADVICE. INHAL: REMOVE TO FRESH AIR
(SUP DAT)
===================== Fire Fighting Measures =====================
Extinguishing Media:SUBSTANCE IS NON-COMBUSTIBLE; USE AGENT MOST
APPROPRIATE TO EXTINGUISH SURROUNDING FIRE.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . USE WATER SPRAY TO KEEP FIRE-EXPOSED CONTAINERS COOL.
SUBSTANCE IS NON-COMBUSTIBLE.
Unusual Fire/Explosion Hazard:STRONG OXIDIZER. CONTACT WITH COMBUSTIBLE
MATERIALS MAY CAUSE A FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB SPILL WITH INERT MATERIAL (E.G., DRY
SAND OR EARTH), THEN PLACE INTO A CHEMICAL WASTE CONTAINER. WEAR
NIOSH APPROVED SCBA & APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT
(SEE CONTROL MEASURES SECTI ON).
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE WITH ADEQUATE VENTILATION. DO NOT
GET IN EYES OR ON SKIN. DO NOT INGEST OR INHALE.
Other Precautions:STORE IN A COOL, DRY, WELL-VENTILATED AREA AWAY FROM
INCOMPATIBLE SUBSTANCES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOLLOW THE OSHA RESPIRATOR REGULATIONS FOUND IN
29CFR 1910.134. ALWAYS USE A NIOSH APPROVED RESPIRATOR WHEN
NECESSARY.
Ventilation:USE ADEQUATE GENERAL OR LOCAL EXHAUST VENTILATION TO KEEP
AIRBORNE CONCENTRATIONS BELOW THE PERMISSIBLE EXPOSURE LIMITS.
Other Protective Equipment:ANSI APPROVED EMERGENCY EYEWASH AND DELUGE
SHOWER . WEAR APPROPRIATE PROTECTIVE CLOTHING TO PREVENT SKIN
EXPOSURE.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. REMOVE
CONTAMINATED CLOTHING AND WASH BEFORE REUSE.
Supplemental Safety and Health
MATLS TO AVOID: MATERIALS AND COMBUSTIBLES. FIRST AID PROC: IMMED. IF
NOT BRTHG, GIVE ARTF RESP. IF BRTHG IS DFCLT, GIVE OXYGEN. GET MED
AID. NOTES TO MD: TREAT SYMPTOMATICALLY & SUPPORTIVELY. NO SPEC
IFIC ANTIDOTE EXISTS.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:187F,86C
Melt/Freeze Pt:M.P/F.P Text:-44F,-42C
Vapor Pres:6.8
Spec Gravity:1.50
pH:1.0
Solubility in Water:SOLUBLE
Appearance and Odor:TRANSPARENT, CLEAR OR YELLOWISH LIQUID. STRONG,
ACRID ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
REACTS W/OVER 150 CHEMICAL COMBINATIONS. REFER TO NFPA FIRE PROT GUIDE
FOR SPECIFICS. REACTS VIOLENTLY W/ORG (SUP DAT)
Stability Condition to Avoid:HIGH TEMPS, INCOMPATIBLE MATERIALS,
MOISTURE, REDUCING AGENTS. DECOMPOSES WHEN IN CONTACT W/AIR,
LIGHT/ORGANIC MATTER.
Hazardous Decomposition Products:NITROGEN OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN A MANNER CONSISTENT WITH FEDERAL,
STATE, AND LOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:4206-1000, WHITE-HIGH HIDING DEVFLEX 4206 INT/EXT (SUP DAT)
CAGE:72818
CAGE:72818
CAGE:01PD6
============= Composition/Information on Ingredients =============
Ingred Name:SOLVENT NAPHTHA, PETROLEUM, MEDIUM ALIPHATIC
CAS:64742-88-7
RTECS #:WF3450000
Fraction by Wt: 1-5%
OSHA PEL:100 PPM (MFR)
ACGIH TLV:100 PPM (MFR)
Ingred Name:ETHANOL, 2-BUTOXY-; (2-BUTOXYETHANOL)
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: 1-5%
OSHA PEL:50 PPM, S
ACGIH TLV:25 PPM, S
Ingred Name:ETHANOL, 2-(2-BUTOXYETHOXY)-
CAS:112-34-5
RTECS #:KJ9100000
Fraction by Wt: 1-5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 10-20%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:SILICA GEL; (SILICA)
CAS:112945-52-5
RTECS #:VV7310000
Fraction by Wt: 1-5%
OSHA PEL:6 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:FORMALDEHYDE (SARA 302/313) (CERCLA) %: 0.01-0.1
CAS:50-00-0
RTECS #:LP8925000
Fraction by Wt: 0.1%
OSHA PEL:SEE 1910.1048
ACGIH TLV:C 0.3 PPM, A2
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 30-40%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ACRYLIC COPOLYMER
CAS:89678-90-0
Fraction by Wt: 5-10%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ALUMINUM HYDROXIDE
CAS:21645-51-2
RTECS #:BD0940000
Fraction by Wt: 5-10%
OSHA PEL:5 MG/M3 (MFR)
ACGIH TLV:10 MG/M3 (MFR)
Ingred Name:STYRENE COPOLYMER
CAS:25750-06-5
Fraction by Wt: 5-10%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:STYRENE ACRYLATE COPOLYMER
CAS:25153-46-2
Fraction by Wt: 5-10%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:VOLATILE ORGANIC COMPOUND: 189.79 G/L
RTECS #:9999999VO
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:EFTS OF OVEREXP: DROW, DIZZ &/OR LT-HEAD, HDCH, UNCOORD,
NAUS, VOMIT, DIARR, GI DISTURBS, SEV ABDOM PAIN, (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13: APATHY, CNS DEPRESS, RESP PROBLEMS, INTOXICATION,
LIVER & KIDNEY DMG, PULM EDEMA, CONVLS, LOSS OF (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14: CONSCIOUSNESS, CYANOSIS, ACUTE POISONING, RESP &
CARD FAILURE, BRAIN DMG, DEATH. CONTAINS CHEM MOD TOX (ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15: BY INGEST. MAY CAUSE TOXICITY TO LIVER, KIDNEY,
LUNGS, BLOOD. MAY BE ABSORBED THRU SKIN. EXCESS INHAL OF(ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16: FUMES MAY LEAD TO METAL FUME FEVER W/METALLIC TASTE
IN MOUTH, EXCESS THIRST, COUGH, WEAK, FATG, MUSC (ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17: PAIN, NAUS, CHILLS & FEVER. NOTICE: RPTS HAVE ASSOC
RPTD & PRLNG OCCUP OVEREXP TO SOLVS W/PERM BRAIN & (ING 19)
RTECS #:9999999ZZ
Ingred Name:ING 18: NERV SYS DMG. INTENTIONAL MISUSE BY DELIB CONC &
INHALING CONTENTS MAY BE HARMFUL/FATAL. SOME LAB TEST (ING 20)
RTECS #:9999999ZZ
Ingred Name:ING 19: RSLTS HAVE SHOWN ETHYLENE GLYCOL TO BE AN ANIMAL
TERATOGEN. CRYSTALLINE SILICA IS A KNOWN CAUSE OF (ING 21)
RTECS #:9999999ZZ
Ingred Name:ING 20: SILICOSIS. ANIMAL STUDIES CLEARLY DEMONSTRATED
DOSE-RELATED ADVERSE EFTS ON CNS, HEMATOPOIETIC TISS, (ING 22)
RTECS #:9999999ZZ
Ingred Name:ING 21: BLOOD, KIDNEYS & LIVER, ASSOC W/ADMIN OF
2-BUTOXYETHANOL (EXTRACTED FROM DHHS (NIOSH) PUB #90-118) .
RTECS #:9999999ZZ
Ingred Name:EXPLAN OF CARCIN: 1994: ANTICIPATED TO BE CARCINOGEN. OSHA
REGULATED: 29 CFR 1910.1048. ANIMAL: NASAL TUMORS.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC: IF SUCH CNDTNS CANNOT BE AVOIDED, USE APPROP
NIOSH APPRVD RESP PROT AS DIRECTED. EMPTY CONTRS MAY (ING 25)
RTECS #:9999999ZZ
Ingred Name:ING 24: CONTAIN HAZARDOUS RESIDUES. GROUND EQUIPMENT WHEN
TRANSFERRING TO PREVENT ACCUMULATION OF STATIC CHARGE.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: INHAL: IRRIT OF RESP TRACT.
PRLNG INHAL MAY LEAD TO MUC MEMB IRRIT, DROW, DIZZ &/OR LT-HEAD,
HDCH, NAUS, VOMIT, GI DISTURBS, CHEST PAIN, COUGH, SPEECH DFCLTY,
APATHY, CNS DEPRESS, ANESTH EFT/NA RCOSIS, BLOOD ABNORMS, KIDNEY
DMG, LOSSOF CONSCIOUSNESS. POSS SENSIT TO RESP TRACT. SKIN: IRRIT.
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:CONTAINS 2-A [53-96-3]
WHICH IS LISTED BY NTP AND IARC AND REGULATED BY OSHA AS A
CARCINOGEN.
Effects of Overexposure:HLTH HAZ: PRLNG/RPTD CONT CAN CAUSE DERM,
DEFAT. POSS SENSIT. DERMAL ABSORPTION MAY CAUSE HDCH, NAUS, VOMIT,
APATHY. EYE: IRRIT. PRLNG/RPTD CONT CAN CAUSE CONJ, BLURRED VISION,
TEARING, REDNESS, SEV I RRIT/BURNS, CORNEAL INJURY. INGEST:
MAYCAUSE LUNG INFLAMM & DMG DUE TO ASPIR OF MATL INTO LUNGS, FATG,
(ING 13)
Medical Cond Aggravated by Exposure:EYE, SKIN, RESPIRATORY, LUNG, AND
KIDNEY DISORDERS. ASTHMA-LIKE CONDITIONS.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. RESTORE & SUPPORT BRTHG. GET EMER
MED ATTN. HAVE TRAINED PERS GIVE OXYGEN IF NEC. GET MED HELP FOR
ANY BRTHG DFCLTY. SKIN: FLUSH W/WATER. THEN WASH THORO W/SOAP &
WATER. RE MOVE CONTAM CLTHG & WASH BEFORE REUSE. DISP OF CONTAM
LEATHER ITEMS (SHOES, BELTS). IF IRRIT OCCURS, CONSULT MD. EYE:
FLUSH IMMED W/LGE AMTS OF WATER, ESP UNDER LIDS FOR AT LEAST 15
MIN. (SUP DAT)
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:DRY CHEMICAL OR FOAM WATER FOG. CARBON DIOXIDE.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . WATER MAY BE USED TO COOL AND PROTECT EXPOSED
CONTAINERS.
Unusual Fire/Explosion Hazard:VAPS HVR/AIR & MAY TRAVEL LONG DISTS TO
SOURCE OF IGNIT & FLASH BACK. CLSD CONTRS MAY BURST IF EXPOSED TO
EXTREME HEAT/FIRE. MAY DECOMPOSE UNDER FIRE (SUP DAT)
================== Accidental Release Measures ==================
Spill Release Procedures:COMPLY W/ALL APPLIC HLTH & ENVIRON REGS. ELIM
ALL SOURCES OF IGNIT. VENT AREA. SPILLS MAY BE COLLECTED W/ABSORB
MATLS. USE NON-SPKG TOOLS. EVACUATE ALL UNNEC PERS. PLACE COLLECTED
MATL IN PROPER CONTR . CONT NEHC FOR MORE SPECIFIC INFORMATION .
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE <100F. KEEP AWAY FROM HEAT, SPKS
& OPEN FLAME. KEEP FROM FREEZING. DO NOT STORE IN ALUMINUM CONTRS.
KEEP CONTRS TIGHTLY CLSD IN WELL-VENTD AREA.
Other Precautions:USE ONLY W/ADEQ VENT. DO NOT TAKE INTERNALLY. KEEP
OUT OF REACH OF CHILDREN. AVOID CONT W/SKIN & EYES, & BRTHG OF
VAPS. AVOID CNDTNS WHICH RSLT IN INHALABLE PARTICLES SUCH AS
SPRAYING/ABRADING (SANDIN G) PAINTED SURFS. (ING 24)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:CONTROL ENVIRONMENTAL CONCENTRATIONS BELOW
APPLICABLE STANDARDS. WHERE RESPIRATORY PROTECTION IS REQUIRED, USE
ONLY NIOSH APPROVED RESPIRATORS IN ACCORDANCE WITH OSHA STANDARD 29
CFR 1910.134.
Ventilation:PROVIDE DILUTION VENTILATION OR LOCAL EXHAUST TO PREVENT
BUILD-UP OF VAPORS. USE EXPLOSION-PROOF EQUIPMENT.
Other Protective Equipment:EMERGENCY EYEWASH AND DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA . WEAR IMPERVIOUS CLOTHING, APRON.
Work Hygienic Practices:WASH HANDS THOROUGHLY AFTER HANDLING, AND
ESPECIALLY BEFORE EATING OR SMOKING.
Supplemental Safety and Health
TRADE NAME/PART #:WATERBORNE ACRYLIC SEMI-GLOSS ENAMEL. EXPLO HAZ:
CNDTNS EMITTING IRRIT &/OR TOX GASES. MAY BE FLAM IN FINELY DIVIDED
& SUSPENDED STATE. IN CLSD TANKS, WATER/FOAM MAY CAUSE FROTHING/E
RUPTION. FIRST AID PROC: IF IRRIT/OTHEREFTS PERSIST, GET MED
TREATMENT. INGEST: GET MED TREATMENT IMMED.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>212F,>100C
Spec Gravity:1.25
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:58.32
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS, ACIDS, REDUCING AGENTS, BASES, ALKALIS, ALUMINUM, ZINC,
METALS, PEROXIDES, NITRIC ACID, MAGNESIUM, NITRATES.
Stability Condition to Avoid:ELEVATED TEMPERATURES. CONTACT W/OXIDIZING
AGENTS. HIGH CONC OF DUST. FREEZING, SPARKS, OPEN FLAME, IGNITION
SOURCES.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
OXIDES OF NITROGEN, OXYGEN, LEAD OXIDE, TOXIC GASES, UNIDENTIFIED
ORGANIC COMPOUNDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH ALL APPLICABLE
REGULATIONS. AVOID DISCHARGE TO NATURAL WATERS. DISPOSE OF IN
ACCORDANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS .
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:865 9591 COM PROFESSIONAL DEVELOPER AND REPLENISHER, W.S.
CAGE:19139
CAGE:19139
CAGE:5K871
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 85-90%
Other REC Limits:NONE RECOMMENDED
Ingred Name:POTASSIUM SULFITE
CAS:10117-38-1
RTECS #:WT3530000
Fraction by Wt: 5-10%
Other REC Limits:NONE RECOMMENDED
Ingred Name:HYDROQUINONE (SARA 302/313) (CERCLA)
CAS:123-31-9
RTECS #:MX3500000
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3; 9596
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:DIETHYLENE GLYCOL
CAS:111-46-6
RTECS #:ID5950000
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:POTASSIUM CHLORIDE
CAS:7447-40-7
RTECS #:TS8050000
Fraction by Wt: < 1%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT): NOT GIVEN
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EXPECTED TO BE A LOW INHALATION HAZARD
FOR RECOMMENDED HANDLING. MAY LIBERATE SULFUR DIOXIDE GAS WHICH IS
IRRITATING TO RESPIRATORY TRACT. EYE CONTACT CAUSES IRRITATION. MAY
CAUSE ALLERGIC SKIN REACTI ON. PROLONGED/REPEATED SKIN CONTACT
MAYCAUSE IRRITATION. HARMFUL IF SWALLOWED. CAN CAUSE KIDNEY DAMAGE
AND CNS EFFECTS.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:KIDNEY DAMAGE, CNS EFFECTS, DIFFICULT
BREATHING, EYE IRRITATION, ALLERGIC SKIN REACTION, SKIN IRRITATION,
WHEEZING, CHEST TIGHTNESS, STOMACH UPSET, HIVES, FAINTNESS,
WEAKNESS, DIARRHEA.
Medical Cond Aggravated by Exposure:SOME ASTHMATICS OR
SULFITE-SENSITIVE INDIVIDUALS MAY EXPERIENCE WHEEZING, CHEST
TIGHTNESS, STOMACH UPSET, HIVES, FAINTNESS, WEAKNESS, DIARRHEA.
======================= First Aid Measures =======================
First Aid:INHALATION: IF SYMPTOMATIC, MOVE TO FRESH AIR. GET MEDICAL
ATTENTION IF SYMPTOMS PERSIST. EYES: WASH OUT IMMEDIATELY WITH
WATER. GET MEDICAL ATTENTION IF SYMPTOMS OCCUR. SKIN: WASH WITH
SOAP AND WATER . GET MEDICAL ATTENTION IF SYMPTOMS OCCUR.
INGESTION: ONLY INDUCE VOMITING AT INSTRUCTION OF MEDICAL
PERSONNEL. NEVER GIVE ANYTHING BY MOUTH IF UNCONSCIOUS. CALL
PHYSICIAN OR POISON CONTROL ASAP.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:NONFLAMMABLE. USE EXTINGUISHING MEDIA SUITABLE FOR
SURROUNDING FIRE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING. FIRE OR EXCESSIVE HEAT MAY PRODUCE HAZARDOUS
DECOMPOSITION PRODUCTS.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH TO SEWER IF ALLOWABLE WITH LARGE AMOUNTS
OF WATER. OTHERWISE, ABSORB SPILL WITH VERMICULITE OR OTHER INERT
MATERIAL, THEN PLACE IN A CONTAINER FOR CHEMICAL WASTE. CLEAN
SURFACE TO REMOVE RESIDUA L CONTAMINATION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID BREATHING VAPOR/MIST. AVOID
CONTACT WITH EYES, SKIN AND CLOTHING. USE WITH ADEQUATE
VENTILATION. KEEP FROM CONTACT WITH OXIDIZING MATERIALS.
Other Precautions:KEEP CONTAINER CLOSED.THE ROUTINE USE OF A
NONALKALINE (ACID) TYPE OF HAND CLEANER AND REGULAR CLEANING OF
WORKING SURFACES WILL HELP MINIMIZE THE POSSIBILITY OF A SKIN
REACTION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED. A RESPIRATOR SHOULD BE
WORN IF HAZARDOUS DECOMPOSITION PRODUCTS ARE LIKELY TO BE RELEASED
OR HAVE BEEN RELEASED. RESPIRATOR TYPE: ACID GAS.
Ventilation:GOOD GENERAL VENTILATION, TYPICALLY 10 AIR CHANGES PER
HOUR, SHOULD BE USED. RATES SHOULD MATCH CONDITIONS.
Other Protective Equipment:CHEMICAL RESISTANT CLOTHING AS NECESSARY TO
PREVENT SKIN CONTACT. AN EMERGENCY EYEWASH AND SHOWER SHOULD BE
AVAILABLE.
Work Hygienic Practices:WASH HANDS THOROUGHLY WITH SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES.
Supplemental Safety and Health
REMOVE AND WASH CONTAMINATED CLOTHING BEFORE REUSE.
================== Physical/Chemical Properties ==================
HCC:B3
Boiling Pt:B.P. Text:NOT GIVEN
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Decomp Temp:Decomp Text:NOT GIVEN
Vapor Pres:18
Vapor Density:0.6
Spec Gravity:1.084
pH:10.9
Viscosity:NOT GIVEN
Evaporation Rate & Reference:NOT GIVEN
Solubility in Water:COMPLETE
Appearance and Odor:YELLOW LIQUID, NO ODOR
Percent Volatiles by Volume:85-90%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
SULFUR DIOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT OR DISPOSAL MAY BE SUBJECT
TO NATIONAL, STATE OR LOCAL LAWS. MAY REQUIRE NEUTRALIZATION IF PH
< 2.0 OR PH > 12.5. DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE ANDLOCAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:HD0111
Preparer's Name:PHIL PERKINS
CAGE:0KZ46
CAGE:12405
CAGE:0KZ46
============= Composition/Information on Ingredients =============
Ingred Name:TRIETHYLENE TETRAMINE (TETA)
CAS:112-24-3
RTECS #:YE6650000
Fraction by Wt: 65-75%
Ingred Name:ETHYLENEAMINES; (OTHER ETHYLENEAMINES)
Fraction by Wt: 25-35%
Ingred Name:TRIETHYLENE TETRAMINE (CONTAINS INGS 2 & 3)
CAS:112-24-3
RTECS #:YE6650000
Fraction by Wt: 35-60%
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(ORAL,RAT) 4340 MG/KG.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES:MAY CAUSE PAIN. MAY CAUSE SEV
IRRIT W/CORNEAL INJURY WHICH MAY RESULT IN PERM IMPAIRMENT OF
VISION, EVEN BLINDNESS. SKIN:SHORT SINGLE EXPOS MAY CAUSE SEV SKIN
BURNS. IS LIKELY TO CAUSE ALLERGIC R XN. A SINGLE PRLNG EXPOS MAY
RESULT IN MATL BEING ABSORBED IN HARMFUL AMOUNTS. LD50 FOR SKIN
ABSORPTION(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:IN RABBITS IS 800 MG/KG. INGEST:SINGLE
DOSE ORAL TOX IS LOW. INGEST MAY CAUSE GI IRRIT OR ULCERATION. MAY
CAUSE BURNS OF MOUTH & THROAT. INHAL:MAY CAUSE RESP SENSIT IN
SUSCEPTIBLE INDIVIDUALS . EXCESSIVE EXPOS MAY CAUSE IRRIT TO UPPER
RESP TRACT.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES:IMMED & CONTINUOUS IRRIGATION W/FLOWING WATER FOR @ LST
30 MINS IS IMPERATIVE. PROMPT MED CONSULTATION IS ESSNTL.
SKIN:IMMED FLUSH W/PLENTY OF WATER FOR @ LST MINS WHILE REMOVING
CONTAM CLTHG, PR EF UNDER SAFETY SHOWER. CALL MD IF IRRIT PERSISTS.
AVOID PRLNG/RPTD CONT W/SKIN. WASH THORO AFTER HNDLG. INGEST:DO NOT
INDUCE VOMIT. GIVE LG AMTS OF WATER/MILK IF AVAIL & TRANSPORT TO
MED (SUPP DATA)
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:290F,143C
Lower Limits:1%
Upper Limits:6.5%
Extinguishing Media:DRY CHEMICAL, FOAM OR CARBON DIOXIDE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE IGNITION SOURCES & PROVIDE ADEQUATE
VENTILATION. COVER SPILL W/ABSORBENT MATERIAL & REMOVE TO WASTE
CONTAINER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN CLOSED CONTAINERS IN A COOL,
DRY AREA AWAY FROM HEAT, SPARKS & OPEN FLAMES. USE ONLY W/ADEQUATE
VENTILATION.
Other Precautions:AVOID PROLONGED OR REPEATED BREATHING OF VAPORS OR
CONTACT W/SKIN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR A PROPERLY FITTED NIOSH/MSHA APPROVED SCBA
OR INDUSTRIAL TYPE CANISTER MASK IN ENCLOSED AREAS W/POOR OR NO
VENT SYSTEM. IF AIR CONTAM IS SUSPECTED, THE CONTAM SHOULD BE
VARIFIED BY AIR MONITORINGBEFORE SELECTION OF RESP PROT IS MADE.
Ventilation:LOCAL EXHAUST PREFERRED. MECHANICAL ACCEPTABLE.
Other Protective Equipment:HYDROCARBON INSOLUBLE APRONS, EYE WASH,
SAFETY SHOWER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRST AID PROC:FACILITY. INHAL:REMOVE TO FRESH AIR IF EFFECTS OCCUR.
CONSULT MD.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:530F,277C
Vapor Pres:<0.01
Spec Gravity:1.09
Evaporation Rate & Reference:<0.01 (BUTYL ACETATE=1)
Solubility in Water:40%
Appearance and Odor:AMBER, LOW VISCOSITY LIQUID; PETROLEUM & AMMONIA
ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NITROGEN OXIDES, CARBON MONOXIDE,
CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:SHOULD BE I/A/W FEDERAL, STATE & LOCAL
ENVIRONMENTAL CONTROL REGULATIONS. THIS MAY BE A CORROSIVE WASTE
UNDER THE RCRA.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:ISOVUE 300 (ISOPAMIDOL INJECTION 61%)
Preparer's Name:DR. E. HAYES
CAGE:BRIST
CAGE:0NWX1
CAGE:BRIST
============= Composition/Information on Ingredients =============
Ingred Name:IOPAMIDOL
CAS:60166-93-0
RTECS #:CZ2235000
Fraction by Wt: 23-54%
Other REC Limits:NONE RECOMMENDED
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: >1%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE ESRABLISHED.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ISOVUE SOLUTIONS ARE INTENDED FOR
INTRAVENOUS ADMINISTRATION. ORAL: NO INFORMATION. DERMAL: NO
INFORMATION. INHALATION: THIS PRODUCT IS A LIQUID AND UNDER NORMAL
CONDITIONS OF USE IS NOT AN INHALATION HAZARD.
Explanation of Carcinogenicity:NOT CARCINOGENIC.
Effects of Overexposure:ADVERSE REACTIONS HAVE BEEN REPORTED FOLLOWING
INTRAVENOUS ADMINISTRATION OF ISOVUE SOLUTIONS, INCLUDING:
HEADACHE, NAUSEA, VOMITING, MUSCULOSKELETAL PAIN; AND HYPOTENSION.
Medical Cond Aggravated by Exposure:SENSITIVITY TO IODINE.
======================= First Aid Measures =======================
First Aid:EYE-FLUSH WITH LARGE AMOUNTS OF WATER FOR 15-20 MINUTES.
SKIN-WASH WITH SOAP & WATER. GET MEDICAL ATTENTION IF IRRITATION
DEVELOPS & PERSISTS. INGESTION-GET MEDICAL ATTENTION IMMEDIATELY.
VOMITING MAY BE INDUCED IF A PERSON IS CONSCIOUS & IF INGESTION
HAS OCCURERED WITH 3 HOURS. INHALATION-REMOVE TO FRESH AIR, IF
DIFFICULTY IN BREATHING ADMINISTER OXYGEN. IF NOT BREATHING ATTEMPT
CPR. SEE DOCTOR.
===================== Fire Fighting Measures =====================
Flash Point:NOT AVAILABLE
Extinguishing Media:USE WATER.
Fire Fighting Procedures:AS WITH ALL FIRES, EVACUATE PERSONNEL TO SAFE
AREA. WHEN THIS MATERIAL IS INVOLVED IN A FIRE WEAR, SELF-CONTAINED
BREATHING APPARATUS & FULL PROTECTIVE CLOTHING
Unusual Fire/Explosion Hazard:USE WATER TO KEEP FIRE-EXPOSED CONTAINERS
COOL. FIGHT FIRE FROM MAXIMUM SAFE DISTANCE. DIVERT RUNOFF TO A
SAFE AREA.
================== Accidental Release Measures ==================
Spill Release Procedures:WEARING SUITABLE PROTECTIVE CLOTHING, ABSORB
LIQUID ONTO APPROPIATE ABSORBENT MATERIAL & PLACE INTO AN
SHOULD BE WORN AS A MINIMUM PREC AUTION. VENTILATE SPILL AREA &
DECONTAMINATE LATER
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AT ROOM TEMPERATURE NOT
EXCEEDING 86 DEGREES F. PROTECT FROM LIGHT.
Other Precautions:IF VIALS BREAK OR MATERIAL IS SPILLED, WORKERS SHOULD
AVOID SKIN OR EYE CONTACT WITH THE LIQUID. PERSONNEL WHO HANDLE
THESE FORMULATIONS IN A NON-MANUFACTURING SETTING SHOULD USE LATEX
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SPECIFIED BY MANUFACTURER.
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:GOWN.
Work Hygienic Practices:WORKERS SHOULD WASH THEIR HANDS AND FACES AFTER
HANDLING THESE FORMULATIONS.
Supplemental Safety and Health
PROMPTLY REMOVE CONTAMINATED CLOTHING SHOULD CONTACT OCCUR. WASH
CONTAMINATED CLOTHING BEFORE REUSE.
================== Physical/Chemical Properties ==================
HCC:N1
pH:6.5-7
Solubility in Water:MISCIBLE
Appearance and Odor:AQUEOUS SOLUTION.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:STABLE UNDER NORMAL CONDITIONS.
Hazardous Decomposition Products:THERMAL DECOMPOSITION OR BURNING MAY
PRODUCE NOXIOUS PRODUCTS INCLUDING: CO, CO2, HI, I2 (REDDISH-BROWN
GAS), NOX.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE
AND FEDERAL REGULATIONS OR WITH THE REGULATIONS OF THE COUNTRY IN
WHICH THE MATERIAL IS USED.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:CLEAR COAT 4-2-1, EPOXY RESIN
Kit Part:Y
CAGE:CLCOA
CAGE:CLCOA
CAGE:0WTR8
============= Composition/Information on Ingredients =============
Ingred Name:BISPHENOL A-EPICHLOROHYDRIN COPOLYMER; (BISPHENOL A
DIGLYCIDYL ETHER RESIN)
CAS:25068-38-6
RTECS #:SL6475000
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPDAT:EARTH, FLOOR ABSORBENT, OR OTHER ABSORBENT MATERIAL
AND SHOVELED INTO CONTAINERS.
RTECS #:9999999ZZ
Ingred Name:RESP PROT:PERMIT OTHER NIOSH/MSHA APPRVD RESPIRATORS UNDER
SPECIFIED CNDTNS. (SEE YOUR SFTY EQUIP SUPPLIER).
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:SKIN:PROLONGED OR REPEATED
CONTACT CAN CAUSE MODERATE IRRITATION, DEFATTING, DERMATITIS.
INHALATION:EXCESSIVE INHALATION OF VAPORS CAN CAUSE NASAL AND
RESPIRATORY IRRITATION, DIZZINESS, WEAKNESS , FATIGUE, NAUSEA,
HEADACHE, POSSIBLE UNCONSCIOUSNESS, AND EVEN ASPHYXIATION.
INGESTION:CAN CAUSE (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:GASTROINTESTINAL IRRITATION, NAUSEA,
VOMITING, AND DIARRHEA. CHRONIC:NOTICE:REPORTS HAVE ASSOCIATED
REPEATED & PROLONGED OVEREXPOSURE TO SOLVENTS WITH PERMANENT BRAIN
& NERVOUS SYSTEM DAMAGE. INTENTIONAL MISUSE BY DELIBERATELY
CONCENTRATING & INHALING THE CONTENTS MAY BE HARMFUL OR FATAL.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:SKIN:THORO WASH EXPOS AREA W/SOAP & WATER. REMOVE CONTAMD
CLTHG. LAUNDER CONTAMD CLTHG BEFORE REUSE. EYES:FLUSH W/LG AMTS OF
WATER FOR @ LEAST 15 MINS, LIFTING UPPER & LOWER LIDS OCCASNLY, GET
MED ATT N. INGEST:DO NOT INDUCE VOMIT. CALL PHYS/TRANSPORT TO AN
EMER FACILITY. INHAL:IF AFFECTED, REMOVE INDIVIDUAL TO FRESH AIR.
IF BRTHG IS DFCLT, ADMIN OXYG. IF BRTHG HAS STOPPED GIVE ARTF RESP.
(SUPDAT)
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:490F,254C
Extinguishing Media:WATER FOG OR CARBON DIOXIDE OR DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:VAP ARE HVR/AIR & MAY TRAVEL ALONG
GROUND/MAY BE MOVED BY VENT & IGNITED BY PILOT LIGHTS, OTHER
FLAMES, SPKS, HEATERS, SMKNG, ELEC MOTORS/OTHER IGNIT (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:ELIM ALL IGNIT SOURCES (FLARES, FLAMES INCLDG
PILOT LIGHTS, ELEC SPKS). PERSONS NOT WEARING PROT EQUIP SHOULD BE
EXCLUDED FROM AREA OF SPILL UNTIL CLEAN-UP HAS BEEN COMPLETED. STOP
SPILL AT SOURCE, DI KE AREA OF SPILL TO PVNT SPREADING, PUMP
(SUPDAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:CONTAINERS OF THIS MATERIAL MAY BE
HAZARDOUS WHEN EMPTIED.
Other Precautions:SINCE EMPTIED CONTAINERS RETAIN PRODUCT RESIDUES
(VAPOR, LIQUID, AND/OR SOLID), ALL HAZARD PRECAUTIONS GIVEN IN THIS
MSDS MUST BE OBSERVED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPRVD RESP APPROP FOR EXPOS OF
CONCERN . IF TLV OF PROD/ANY COMPONENT IS EXCEEDED, NIOSH/MSHA
JOINTLY APPRVD SCBA W/FULL FACE PIECE OPERATED IN PRESS
DEMAND/OTHER POS PRESS MODE IS A DVISED: HOWEVER, OSHA REGS ALSO
(ING 3)
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GEN) AND/OR LOC EXHAUST VENT
TO MAINTAIN EXPOS BELOW TLV(S).
Other Protective Equipment:IMPERVIOUS CLOTHING AND BOOTS. ANSI APPRVD
EMERGENCY EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EXPLO HAZ:SOURCES @ LOCATIONS DISTANT FROM MATL HNDLG POINT. NEVER USE
WELDING/CUTTING TORCH ON OR NEAR DRUM (EVEN EMPTY) BECAUSE PROD
(EVEN DUST RESIDUE) CAN IGNITE EXPLOSIVELY. FIRST AID PROC:KEEP P
ERSON WARM, QUIET & GET MED ATTN. SPILLPROC:LIQ TO SALVAGE TANK.
REMAINING LIQ MAY BE TAKEN UP ON SAND, CLAY, (ING 2)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:392F,200C
Vapor Density:HVR/AIR
Spec Gravity:1.17 (H*2O=1)
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NOT KNOWN
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:NIL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENT, STRONG ALKALIES, STRONG MINERAL ACIDS.
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAMES.
Hazardous Decomposition Products:MAY FORM TOXIC MATERIALS:CARBON
DIOXIDE AND CARBON MONOXIDE, VARIOUS HYDROCARBONS, ETC.
==================== Disposal Considerations ====================
Waste Disposal Methods:MATERIAL COLLECTED ON ABSORBENT MATERIAL MAY BE
DEPOSITED IN A POSTED TOXIC SUBSTANCE LANDFILL IN ACCORDANCE WITH
LOCAL, STATE, AND FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:844 5769, SODIUM SULFATE
CAGE:19139
CAGE:19139
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM SULFATE DECAHYDRATE (GLAUBER'S SALT)
CAS:7757-82-6
RTECS #:WE1650000
Fraction by Wt: 100%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL RAT) = 3200-6400 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION:LOW HAZARD FOR RECOMMENDED
HANDLING. EYE:NO SPECIFIC HAZARD KNOWN. MAY CAUSE TRANSIENT
IRRITATION. SKIN:LOW HAZARD FOR RECOMMENDED HANDLING.
INGESTION:EXPECTED TO BE LOW INGESTION HAZARD.
Explanation of Carcinogenicity:IN ADDITION TO THE ABOVE, PRODUCT IS
NEGATIVE W/REGARD TO:ACGIH CANCER, CALIFORNIA CANCER & REPRODUCTIVE
EFFECTS.
Effects of Overexposure:INHALATION:LOW HAZARD FOR RECOMMENDED HANDLING.
EYE:NO SPECIFIC HAZARD KNOWN. MAY CAUSE TRANSIENT IRRITATION.
SKIN:LOW HAZARD FOR RECOMMENDED HANDLING. INGESTION:EXPECTED TO BE
LOW INGESTION HAZARD.
Medical Cond Aggravated by Exposure:MFR GAVE NO INFORMATION OF MSDS..
======================= First Aid Measures =======================
First Aid:IF ANY SYMPTOMS OCCUR, GET IMMEDIATE MEDICAL ATTENTION.
INHALATION:IF SYMPTOMATIC, MOVE TO FRESH AIR. EYE:FLUSH W/PLENTY OF
WATER FOR 15 MIN. SKIN:FLUSH W/WATER 15 MIN. REMOVE CONTAMINATED
CLOTHING &LAUNDER BEFORE REUSE. INGESTION:DRINK 1-2 GLASSES OF
WATER. GET IMMEDIATE MEDICAL ATTENTION. NOTHING BY MOUTH IF
UNCONSCIOUS.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE APPROPRIATE AGENT FOR ADJACENT FIRE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS &
PROTECTIVE CLOTHING. FIRE OR EXCESSIVE HEAT MAY PRODUCE HAZARDOUS
DECOMPOSITION PRODUCTS
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH TO SEWER W/LARGE AMOUNTS OF WATER.
OTHERWISE, SWEEP UP & PLACE IN CONTAINER FOR CHEMICAL WASTRE. CLEAN
SURFACE THOROUGHLY TO REMOVE RESIDUAL CONTAMINATION.
Neutralizing Agent:MFR GAVE NO INFORMATION OF MSDS.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED.
Ventilation:USE GOOD GENERAL VENTILATION (10 CHANGES/HR). MATCH
VENTILATION RATES TO CONDITIONS.
Other Protective Equipment:EYE BATH, WASHING FACILITIES, SAFETY SHOWER.
PROTECTIVE CLOTHING APPROPRIATE FOR THE RISK OF EXPOSURE.
Work Hygienic Practices:EK: ? HMIS:USE GOOD INDUSTRIAL HYGIENE
PRACTICES. MINIMIZE PERSONAL CONTACT. WASH THOROUGHLY AFTER
HANDLING.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:N1
NRC/State Lic Num:NONE
Melt/Freeze Pt:M.P/F.P Text:1630F,888C
Vapor Pres:NEGLIGIBLE
Spec Gravity:2.698
Solubility in Water:SLIGHT
Appearance and Odor:WHITE SOLID, ODORLESS
Percent Volatiles by Volume:NEG.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:MFR GAVE NO INFORMATION OF MSDS.
Hazardous Decomposition Products:SULFUR DIOXIDE
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT, OR DISPOSAL MAY BE SUBJECT
TO NATIONAL, STATE, OR LOCAL LAWS. FLUSH TO SEWER W/LARGE AMOUNTS
OF WATER.
| 1 |
gloves_mandatory
|
=======================================================
Product ID: DUOLITE GT73 RESIN, 61920
Cage: 77902
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 77902
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: NO
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: EYE CONTACT:MATERIAL CAN CAUSE IRRITATION. SKIN
CONTACT:MATERIAL CAN CAUSE SLIGHT IRRITATION. NO TOXICITY DATA ARE AVAILABLE
FOR THIS MATERAIL.
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: INGEST:CALL MD IMMEDIATELY (FP N). INHAL:REMOVE TO FRESH AIR.
SUPPORT BREATHING (GIVE O*2/ARTF RESP) (FP N). EYES:FLUSH W/LARGE AMOUNT OF
WATER FOR AT LEAST 15 MINUTES. CONSULT MD IF IRRITATION PERSIS TS. SKIN:WASH
AFFECTED AREAS THOROUGHLYW/SOAP & WATER.
=======================================================
Handling and Disposal
=======================================================
PROTECTIVE EQUIP SHOULD INCL SAFETY GLASSES (ANSI Z87.1 OR APPRVD EQUIV).
FLOOR MAY BE SLIPPERY; USE CARE TO AVOID FALLING. TRANSFER SPILLED MATL T O
SUITABLE CONTAINERS FOR RECOVERY OR DISPOSAL.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: UNUSED RESIN MAY BE INCIN/LANDFILLED IN FACILITIES
MEETING LOC, STATE & FED REGS. FOR CONTAM RESIN, USER MUST DETERM HAZ
& USE APPROP DISP METH. WHEN A DECISION IS MADE TO DISCARD THIS MATL AS
SUPPLIE D, IT DOES NOT MEET RCRA'S CHARACT (SUPP DATA)
Handling And Storage Precautions: REC STOR TEMP:MIN-0C/32F; MAX-100C/212F. MAX
REC OPERATING TEMP:120C/250F. KEEP FROM FREEZING; MATL STABILITY MAY BE
AFFECTED.
Other Precautions: PROPERLY DESIGNED EQUIP IS VITAL IF THESE RESINS ARE TO BE
USED IN CONJUNCTION W/STRONG OXIDIZING AGENTS SUCH AS NITRIC ACID TO PVNT
RAPID BUILD UP OF PRESS & POSS EXPLO. CONSULT SOURCE KNOWLEDGEABLE IN
HNDLG OF THESE MATLS BEFORE (SUPDAT)
=======================================================
Fire and Explosion Hazard Information
=======================================================
Extinguishing Media: USE FOLLOWING EXTINGUISHING MEDIA WHEN FIGHTING FIRES
INVOLVING THIS MATL: CARBON DIOXIDE, DRY CHEMICAL, WATER SPRAY.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Control Measures
=======================================================
Respiratory Protection: A NIOSH APPROVED RESPIRATORY PROTECTION PROGRAM MEETING
OSHA 1910.134 & ANSI Z88.2 REQUIREMENTS MUST BE FOLLOWED WHENEVER
WORKPLACE CONDITIONS WARRANT A RESPIRATOR'S USE. NONE REQUIRED UNDER NORMAL
OP ERATING CONDITIONS.
Ventilation: VENT SYS EMPLOYED IS DEPENDENT ON USER'S SPECIFIC APPLICATION OF
THIS MATL. REFER TO CURRENT EDITION OF "INDUS
Other Protective Equipment: EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET ANSI
DESIGN CRITERIA (FP N).
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: NOTE:USERS OF "L" VERSION SHOULD CONSULT "LR"
VERSION FOR ADDNL INFO (FP N). WASTE DISP METH: DEFINITION OF IGNITABILITY,
CORROSIVITY/REACTIVITY & IS NOT LISTED IN 40 CFR 261.33. TOX CHARACT
(TC), HOW EVER, HAS NOT BEEN EVAL BY TOX CHARACT LEACHING PROC (TCLP). OTHER
PREC:PROCEEDING. DO NOT PACK COLUMN W/DRY ION
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: 212F,100C
M.P/F.P Text: 32.0F,0.0C
Vapor Pres: 17 @ 20C
Vapor Density: <1
Spec Gravity: 1.1 (H*2O=1)
PH: 6-7
Solubility in Water: PRACTICALLY INSOL
Appearance and Odor: GRAY TO GREEN BEADS; SULFUR ODOR.
Percent Volatiles by Volume: 52-54
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: AVOID TEMPERATURES ABOVE 120C/428F.
Materials To Avoid: AVOID CONTACT W/STRONG OXIDIZING AGENTS, PARTICULARLY
CONCENTRATED NITRIC ACID.
Hazardous Decomposition Products: THERMAL DECOMPOSITION MAY YIELD FOLLOWING:
MONOMER VAPORS - SULFUR OXIDES.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: DUOLITE GT73 RESIN, 61920
Cage: 77902
Company Name: ROHM AND HAAS CO
Street: 100 INDEPENDENCE MALL WEST
Zipcode: 19106-2399
Label Required IND: Y
Date Of Label Review: 12/11/1997
Status Code: C
Label Date: 12/11/1997
Origination Code: G
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE:EYE CONTACT:MATERIAL CAN CAUSE IRRITATION. SKIN
CONTACT:MATERIAL CAN CAUSE SLIGHT IRRITATION. CHRONIC:NONE LISTED BY
MANUFACTURER.
=======================================================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:COATING, POLYURETHANE, AIRCRAFT GRAY, 36300
Kit Part:Y
CAGE:PRATT
CAGE:PRATT
CAGE:61196
============= Composition/Information on Ingredients =============
Ingred Name:PROPYLENE GLYCOL /METHYL ETHER ACETATE (VAPOR PRESSURE 2 MM
HG @ 20 C) (SOLVENT)
CAS:108-65-6
RTECS #:AI8925000
Fraction by Wt: 20%
Other REC Limits:NONE SPECIFIED
OSHA PEL:NONE ESTABLISHED
ACGIH TLV:NONE ESTABLISHED
Ingred Name:XYLENE (SARA 313) (CERCLA)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: <5.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/STEL 150
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:TOLUENE (SARA 313) (CERCLA)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 5.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM/STEL150 SKIN
ACGIH TLV:50 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 20.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:SILICA AMORPHOUS DIATOMACEOUS EARTH PIGMENT
CAS:68855-54-9
Fraction by Wt: 10.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:6 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:SILICA, CRYSTALLINE - CRISTOBALITE
CAS:14464-46-1
RTECS #:VV7325000
Fraction by Wt: 15.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.05 MG/M3
ACGIH TLV:0.05 MG/M3
Ingred Name:TALC
CAS:14807-96-6
RTECS #:MW2700000
Fraction by Wt: 5.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA 313) (CERCLA)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 10.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:200 PPM
ACGIH TLV:200 PPM/STEL 300
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:OVEREXPOSURE TO CRYSTALLINE SILICA MAY
CAUSE SILICOSIS. MAY BE ABSORBED THROUGH SKIN. POSSIBLE LIVER
DAMAGE/PRE-EXISTING RESPRIATORY PROBLEMS/PERIPHERAL
NEUROPATHY/PERMANENT BRAIN AND NERVOUS SYSTEM D
AMAGE/KIDNEY/LUNG/SPLEEN DAMAGE. PERIPHERAL NEUROPATHY IN HUMANS.
POSSIBLE BRAIN/NERVOUS SYSTEM DAMAGE.
Effects of Overexposure:INGESTION: GASTROINTESTINAL IRRITATION/
NAUSEA/VOMITING/CHEMICAL PNEUMONITIS. INHALATION: NOSE/THROAT
IRRITATION- HIGH CONCENTRATIONS: CENTRAL NERVOUS SYSTEM
DEPRESSION-HEADACHES/DIZZINESS/ NAUSEA/CON FUSION. EYE: SEVERE
IRRITATION/CORNEAL DAMAGE. SKIN: MAY CAUSE SEVERE SKIN IRRITATION.
======================= First Aid Measures =======================
First Aid:INGESTED: DO NOT INDUCE VOMITING-POISON CENTER/HOSPITAL OR
PHYSICIAN IMMED. INHALATION. REMOVE TO FRESH AIR IMMED. ARTIFICIAL
RESPIRATION IF NECESSARY. WARM/QUIET. IMMED MED ATTEN. EYES: FLUSH
W/LG AM TS H2O, 15 MIN LIFT LIDS OCCATIONALLY MED ATTEN. SKIN:
REMOVE CONTAM CLOTHES. WASH SKIN W/SOAP & WATER. GET MED AID IF
IRRIT PERSISTS.
===================== Fire Fighting Measures =====================
Flash Point:24.0F,-4.4C
Lower Limits:1.0
Upper Limits:10.0
Extinguishing Media:NFPA CLASS B EXTINGUISHERS (CARBON DIOXIDE/DRY
CHEMICAL/ALCOHOL FOAM)-FLAM LIQ FIRES. POLYMER FOAM FOR LARGE
FIRES.
Fire Fighting Procedures:WATER FOG TO COOL CONTAINERS-PREVENT PRESSURE
BUILD-UP/AUTO-IGNITION/EXPLOSION.
Unusual Fire/Explosion Hazard:DURING EMERGENCY CONDITIONS, OVEREXPOSURE
TO DECOMPOSITION PRODUCTS MAY CAUSE A HEALTH HAZARD, SYMPTOMS NOT
IMMEDIATELY APPARENT. OBTAIN MEDICAL ATTENTION.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE AREA. NO IGNITION SOURCES: FLAMES/
HOT SURFACES/ELECTRICAL, STATIC, OR FRICTIONAL SPARKS. DIKE AND
ABSORB SPILL W/INERT ABSORBANT. TRANSFER TO METAL CONTAINER
W/NON-SPARKING TOOLS. NO CONTAM. SEWERS, STREAMS OR GROUNDWATER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 115 F STORE LARGE
QUANTITIES IN COMPLIANCE WITH OSHA 29CFR1910.106.
Other Precautions:NO INGESTION. KEEP CONTAINERS CLOSED. NO INHALATION
OF SANDING DUST. NO RE-USE OF CONTAINERS. NO WELD/BRAZE/CUT EMPTY
CONTAINERS. NEVER USE PRESSURE TO EMPTY. DRUM IS NOT A PRESSURE
VESSEL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESTRICTED VENTILATION USE NIOSH APPROVED
CHEMICAL CARTRIDGE RESPIRATOR. IF SPRAYING--MECHANICAL PREFILTER.
CONFINED AREA-- NIOSH/MSHA APPROVED RESPIRATOR W/APPROPRIATE
PROTECTION FACTOR. SEE OSHA 29 CFR 1910.134.
Ventilation:LOCAL VENT--SUFF TO MAINTAIN BELOW NUISANCE DUST & EXPOSURE
LIMITS.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:175 TO 281F
Melt/Freeze Pt:M.P/F.P Text:-50F,-46C
Decomp Temp:Decomp Text:1832F,1000C
Vapor Pres:70MMHG@68F
Vapor Density:>AIR
Spec Gravity:1.4
pH:4-7
Evaporation Rate & Reference:SLOWER THAN DIETHYL ETHER
Solubility in Water:SLIGHT
Appearance and Odor:LIQUID, SOLVENT ODOR
Percent Volatiles by Volume:60
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS OR ALKALINE MATERIALS.
Stability Condition to Avoid:EXCESSIVE HEAT (>115 F) AND SOURCES OF
IGNITION.
Hazardous Decomposition Products:BURNING, INCLUDING WHEN HEATED BY
WELDING OR CUTTING, WILL PRODUCE SMOKE, CARBON MONOXIDE AND CARBON
DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS. INCINERATE IN EPA PERMITTED FACILITY. NO INCINERATION
OF CLOSED CONTAINERS. OBSERVE PRECAUTIONS OF FLAMMABLE MATERIALS.
CONTAMINATED ABSORBANT DISPOSED IN HAZARDOUS WASTE LANDFILL.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:WD-40 BULK LIQUID
Preparer's Name:R. MILES,TECH. DIRECTOR
CAGE:09137
CAGE:09137
============= Composition/Information on Ingredients =============
Ingred Name:STODDARD SOLVENT
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 70%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:500 PPM
ACGIH TLV:100 PPM; 9293
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATES, SOLVENT-DEWAXED HEAVY
PARAFFINIC
CAS:64742-65-0
RTECS #:PY8038500
Fraction by Wt: >20%
Other REC Limits:NONE RECOMMENDED
ACGIH TLV:5 MG/M3 (OIL MIST)
Ingred Name:NON HAZARDOUS INGREDIENT
Fraction by Wt: <10%
Other REC Limits:NONE RECOMMENDED
Ingred Name:VOLATILE ORGANIC CONTENT
RTECS #:9999999VO
Fraction by Wt: 568% G/L
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: MAY CAUSE ANESTHESIA,
HEADACHE, DIZZINESS, NAUSEA AND UPPER RESPIRATORY IRRITATION. SKIN
CONTACT: MAY CAUSE DRYING OF SKIN AND/OR IRRITATION. EYE CONTACT:
MAY CAUSE IRRITATION, TEARING AND REDNESS. INGESTION: MAY CAUSE
IRRITATION, NAUSEA, VOMITING AND DIARRHEA
Explanation of Carcinogenicity:THE COMPONENTS IN THIS MIXTURE HAVE BEEN
FOUND TO BE NONCARCINOGENIC BY NTP, IARC AND OSHA.
Effects of Overexposure:EYES: TEARING, REDNESS. SKIN: DRYING.
INHALATION: HEADACHE, DIZZINESS, NAUSEA. INGESTION: NAUSEA,
VOMITING, DIARRHEA.
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH SKIN SENSITIVITY
OR RESPIRATORY CONDITIONS MAY BE MORE ADVERSELY AFFECTED.
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH WITH LARGE AMOUNTS OF WATER FOR AT
LEAST 15 MINUTES. SKIN: WASH WITH SOAP AND WATER. INHALATION:
REMOVE TO FRESH AIR. GIVE ARTIFICIAL RESPIRATION IF NECESSARY. IF
BREATHING IS DIFFICULT, GIVE OXYGEN. INGESTION: DO NOT INDUCE
VOMITING. SEEK MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:TOC
Flash Point:110F,43C
Lower Limits:1.0
Upper Limits:6.0
Extinguishing Media:CARBON DIOXIDE, FOAM, OR DRY CHEMICAL
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB SMALL QUANTITIES WITH SAND, EARTH,
SAWDUST. LARGE QUANTITIES PUMP INTO TANK.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP FROM OPEN FLAME. DO NOT TAKE
INTERNALLY. AVOID EXCESSIVE INHALATION OF SPRAY PARTICLES.
Other Precautions:NONE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:ADVISE WHEN CONCENTRATIONS EXCEED TLV.
Ventilation:SUFFICIENT TO KEEP SOLVENT VAPOR LESS THAN TLV.
Other Protective Equipment:NONE REQUIRED.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. LAUNDER
CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
FLAMMABLE LIQUID. DOO1 (IGNITABLE).
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:300F,149C
Vapor Density:>1 (AIR=1)
Spec Gravity:0.810
Solubility in Water:INSOLUBLE.
Appearance and Odor:CLOUDY, LIGHT AMBER LIQUID, CHARACTERISTIC ODOR.
Percent Volatiles by Volume:74.0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING MATERIALS.
Hazardous Decomposition Products:THERMAL DECOMPOSITION PRODUCTS MAY
YIELD CARBON MONOXIDE AND/OR CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE LIQUID, BURY SATURATED ABSORBENT IN
LANDFILL. DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE AND LOCAL
REGULATIONS.
| 1 |
gloves_mandatory
|
=======================================================
Product ID: ALUMINUM PASTE (LEAFING), 125
Cage: JO693
Box: 2190
=======================================================
Contractor Summary
=======================================================
Cage: 0S7R4
Cage: JO693
Box: 2190
=======================================================
Ingredients
=======================================================
Cas: 7429-90-5
RTECS #: BD0330000
68. MP: 1220F,660C. VAP DENS: N/A.
% Wt: 60-75
OSHA PEL: 15 MG/M3 DUST
ACGIH TLV: 10 MG/M3 DUST
------------------------------
METH: N/K. LEL: 0.35 OZ/FT 3.
-----------------------------
-----------------------------
Cas: 64742-88-7
SOL). BP: >324F,7162C. SPEC GRAV: 0.78
% Wt: 20-35
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
0.07. SOL IN H*2O: NEGLIGIBLE. % VOLT: 100%.
-----------------------------
-----------------------------
Cas: 57-11-4
RTECS #: WI2800000
% Wt: <5
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
IN SEV CASES DEATH MAY OCCUR.
-----------------------------
MED ATTN AS SOON AS POSS. INGEST: DO NOT
-----------------------------
ASPIR INTO LUNGS. GET MED ATTN IMMED.
-----------------------------
-----------------------------
-----------------------------
NITRILE MATERIALS.
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE: ALUMINUM METALLIC POWDER IS AN EYE & MUC MEMB
IRRITANT. HYDROCARBON SOLV IS PRACTICALLY NONIRRITATING TO EYES, SLIGHTLY
IRRITATING TO SKIN (PRLNGD/RPTD LIQ CONT CAN RSLT IN DEFAT & DRYING OF SK
IN WHICH MAY RSLT IN SKIN IRRIT & DERM). HYDROCARBON SOLV VAPS MAY CAUSE
IRRIT TO NOSE, THROAT, & RESP (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: HLTH HAZ: TRACT & HIGH VAP CONCS MAY
RSLT IN CNS DEPRESS. INGEST OF PROD MAY RSLT IN VOMIT; ASPIR (BRTHG) OF
VOMIUS INTO LUNGS MUST BE AVOIDED AS EVEN SM QTYS MAY RSLT IN ASPIR PNEUM.
EARLY TO MOD CNS (CENTRAL NERVOUS SYSTEM) DEPRESS MAY BE EVID BY GIDD, DIZZ,
& NAUS; IN EXTREME CASES, UNCON & DEATH MAY OCCUR. (SUPDAT)
Medical Cond Aggravated By Exposure: PREEXISTING EYE, SKIN, AND RESPIRATORY
DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS PRODUCT.
First Aid: EYE: FLUSH W/PLENTY OF WATER FOR @ LST 15 MINS WHILE HOLDING EYELIDS
OPEN. GET MED ATTN IMMED. CONT LENSES SHOULD NOT BE WORN WHILE WORKING W/THIS
CHEM. SKIN: REMOVE CONTAMD CLTHG/SHOES. FLUSH W/WATER . FOLLOW BY WASHING
W/SOAP & WATER. IF IRRIT OCCURS, GET MED ATTN. DO NOT REUSE CLTHG UNTIL
CLEANED. INHAL: REMOVE VICTIM TO FRESH AIR & PROVIDE OXYG IF BRTHG IS
DFCLT. GIVE ARTF RESP IF
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: NEVER EMPLOY WATER, HAVE SAND PAILS AVAIL. USE
NON-SPK, NON-STATIC GENERATING IMPLEMENTS. STAY UPWIND OF SPILL &
VENTILATE AREA IF INDOORS. KEEP SPILL OUT OF DRAINS, SEWERS & WATERWAYS.
USE SAND/OTHER INERT MATL TO CONTAIN SPILL. PLACE IN
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: OBSERVE ALL LOCAL, STATE AND FEDERAL REGULATIONS WHEN
DISPOSING OF THIS SUBSTANCE.
Handling And Storage Precautions: PROTECT AGAINST WATER. STORE IN A COOL, DRY
PLACE AWAY FROM INCOMPATIBLE CHEMICALS AND POSSIBLE SOURCES OF IGNITION OR
EXPOSURE TO PROLONGED HEAT.
Other Precautions: EMERGENCY CONT: CHEMTREC: (800) 424-9300. TO BE USED "ONLY
IN EVENT OF CHEMICAL EMERGENCIES INVOLVING A SPILL, LEAK, FIRE, EXPOSURE, OR
ACCIDENT INVOLVING CHEMICALS".
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: TCC
Flash Point Text: 111F,44C
Lower Limits: 1.0%
Upper Limits: 7.0%
Extinguishing Media: DRY SAND, DRY INERT GRANULAR MATERIAL OR POWDER, OR
APPROVED DRY POWDER EXTINGUISHING AGENT. DO NOT USE WATER.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Control Measures
=======================================================
Respiratory Protection: IF EXPOSURE MAY OR DOES EXCEED OCCUPATIONAL EXPOSURE
LIMITS USE A NIOSH APPROVED RESPIRATOR TO PREVENT OVEREXPOSURE.
Ventilation: SUFFICIENT VENT, IN BOTH VOL & PATTERN, SHOULD BE PROVIDED TO
KEEP AIR CONTAM BELOW CURRENT APPLIC OSHA
Other Protective Equipment: ANSI APPRVD EYE WASH & DELUGE SHOWER (FP N). OTHER
CLTHG TO MINIMIZE CONT. INDICATIONS FROM LITERATURE AND/
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: MATLS TO AVOID: OXIDES, NITRITES, NITRATES,
CARBON DISULFIDE, DICHLORIDE, PALLADIUM, MANGANESE, MAGNESIUM PLUS POTASSIUM
CHLORATE, SODIUM CARBONATE, SULFATES, DIBORANE, AMINES, CHROMIC ANHYDRIDE,
PROX IDES, CHLORATES. HAZ DECOMP PRODS: MAY YIELD CARBON MONOXIDE AND/OR
CARBON DIOXIDE. EFTS OF OVEREXP: ASPIR PNEUM
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: INGS 1&2
M.P/F.P Text: INGS 1&2
Vapor Pres: INGS 1&2
Vapor Density: INGS 1&2
Spec Gravity: SEE INGS 1&2
Evaporation Rate & Reference: SEE INGS 1 & 2
Solubility in Water: SEE INGS 1 & 2
Appearance and Odor: SILVERY-WHITE PASTE, HYDROCARBON ODOR.
Percent Volatiles by Volume: ING1&2
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: ACIDS, STRONG ALKALIES, STRONG BASES, STRONG OXIDIZERS,
SILVER CHLORIDE, IODATES, CHLORINATED HYDROCARBONS, (SUPDAT)
Hazardous Decomposition Products: ALUMINUM REACTS W/WATER, ACIDS, & ALKALIES TO
FORM COMBUST HYDROGEN GAS. THERMAL DECOMP IN PRESENCE IN AIR (SUPDAT)
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: ALUMINUM PASTE (LEAFING), 125
Cage: JO693
Assigned IND: Y
Company Name: UNITED STATES ALUMINUM INC
Street: ROUTE 202
PO Box: 2190
Zipcode: 08822
Label Required IND: Y
Date Of Label Review: 06/26/1998
Status Code: C
Label Date: 06/26/1998
Origination
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Slight
Fire Hazard: Moderate
Reactivity Hazard: None
Hazard And Precautions: ACUTE: ALUMINUM METALLIC POWDER IS AN EYE & MUC
MEMB IRRITANT. HYDROCARBON SOLV IS PRACTICALLY NONIRRITATING TO EYES,
SLIGHTLY IRRITATING TO SKIN (PRLNGD/RPTD LIQ CONT CAN RSLT IN DEFAT &
DRYING OF SK IN WHICH MAY RSLT IN SKIN IRRIT & DERM). HYDROCARBON SOLV
VAPS MAY CAUSE IRRIT TO NOSE, THROAT, & RESP TRACT & HIGH VAP CONCS
MAY RSLT IN CNS DEPRESS. INGEST OF PROD MAY RSLT IN VOMIT; ASPIR (BRTHG) O F
VOMIUS INTO LUNGS MUST BE AVOIDED AS EVEN SM QTYS MAY RSLT IN ASPIR PNEUM.
EARLY TO MOD CNS DEPRESS MAY BE EVID BY GIDD, DIZZ & NAUS; IN EXTREME
CASES, UNCON & DEATH MAY OCCUR. CHRONIC: NONE LISTED BY MANUFACTURER.
=======================================================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:DEVELOPER, FO-52ND
CAGE:18520
CAGE:18520
============= Composition/Information on Ingredients =============
Ingred Name:MAGNETITE
CAS:1309-38-2
RTECS #:OM4800000
Other REC Limits:NONE RECOMMENDED
Ingred Name:STYRENE ACRYLATE COPLOYMER
Other REC Limits:NONE RECOMMENDED
Ingred Name:POLYPROPYLENE
Other REC Limits:NONE RECOMMENDED
Ingred Name:METAL COMPLEX OF HYDROXYBENZEN COMPOUND
Other REC Limits:NONE RECOMMENDED
Ingred Name:PER MSDS:NONE HAZARDOUS INGREDS
RTECS #:9999999ZZ
Fraction by Wt: NA
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:LDLO VALUE IN AN ACUTE ORAL TOXICITY
TEST IS OVER 5.0G/KG.NO DERMAL IRRITANT REACTIONS ARE ELICITED IN
ANY OF THE RABBITS.NO REACTION OF ACUTE INHAL TOXICITY ARE ELICITED
IN ANY OF THE RATS.
Explanation of Carcinogenicity:PER
MSDS:CARCINOGENICITY:NTP/IARC/OSHA:NO.THIS TONER SHOWS NEGATIVE IN
AMES TEST.
Effects of Overexposure:MINIMAL IRRITATION TO RESPIRATOR TRACT MAY
OCCUR AS WITH EXPOSURE TO ANY NON-TOXIC DUST.
Medical Cond Aggravated by Exposure:ACCUMULATION OF DUST IN THE
RESPIRATORY SYSTEM.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR.IF EFFECTS OCCUR CONSULT LOCAL
MEDICAL PERSONNEL.EYE:IN CASE OF CONTACT IMMED LFUSH EYES W/WAER
FOR 5MINS.
===================== Fire Fighting Measures =====================
Flash Point:NA
Autoignition Temp:Autoignition Temp Text:NP
Lower Limits:NA
Upper Limits:NA
Extinguishing Media:CO2, DRY CHEMICAL, FOAM OR WATER.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS & FULL
PROTECTIVE GEAR
Unusual Fire/Explosion Hazard:MATERIAL HAS NO UNSUAL FIRE OR EXPLO
HAZARDS.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP OR CLEAN UP WITH VACUUM CLEANER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NO SPECIAL STORAGE REQUIREMENTS FOR
SAFETY REASONS.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED UNDER NORMAL USE
Ventilation:LOC EXHAUST/MECHANICAL(GEN)/SPECIAL/OTHER:NO
Other Protective Equipment:NONE REQUIRED UNDER NORMAL USE.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:NA
Melt/Freeze Pt:M.P/F.P Text:NA
Decomp Temp:Decomp Text:NP
Vapor Pres:NA
Vapor Density:NA
Spec Gravity:1.47
pH:NP
Viscosity:NP
Evaporation Rate & Reference:NA
Solubility in Water:NEGLIGIBLE
Appearance and Odor:FINE BLACK POWDER, ODORLESS
Percent Volatiles by Volume:NP
Corrosion Rate:NP
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:CO, CO2, NOX
==================== Disposal Considerations ====================
Waste Disposal Methods:WSTE MATL MAY BE DUMPED OR INCINERATED UNDER
CONDITONS WHICH MEET ALL LOCAL, STATE AND FEDERAL ENVIRONMENTAL
REGULATIONS.
| 0 |
gloves_not_mandatory
|
===================== Product Identification =====================
Product ID:211 CLEAR PRIMER
CAGE:RXVXE
CAGE:RXVXE
============= Composition/Information on Ingredients =============
Ingred Name:ACETONE (SARA 313) (CERCLA). FL PT: 15F,-9C. LEL: 2.6%.
UEL: 12.8%. LD50: (ORAL, RAT) 5800 MG/KG.
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 0-99%
OSHA PEL:1000 PPM
ACGIH TLV:750 PPM; 1000 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:METHYL ETHYL KETONE (SARA 313) (CERCLA). FL PT: 15F,-9C.
LEL: 1.8%. UEL: 10.0%. LD50: (ORAL, RAT) 2737 MG/KG.
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 0-98%
OSHA PEL:200 PPM
ACGIH TLV:200 PPM; 300 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:CYCLOHEXANONE (CERCLA). LD50: (ORAL, RAT) 1535 MG/KG.
CAS:108-94-1
RTECS #:GW1050000
Fraction by Wt: 0-13%
OSHA PEL:50 PPM, S
ACGIH TLV:25 PPM, S
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TETRAHYDROFURAN (CERCLA). LD50: (ORAL, RAT) 1650 MG/KG.
CAS:109-99-9
RTECS #:LU5950000
Fraction by Wt: 0-5%
OSHA PEL:200 PPM
ACGIH TLV:200 PPM; 250 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SUPDAT: TO LEAK/OPEN CNTNR. TETRAHYDROFURAN CAN FORM
POTNTLY EXPLO PEROXIDES; CLSD CNTNRS CONTAM W/PEROXIDES CAN (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5: RUPTURE VIOLENTLY IN HEAT OF FIRE. VAPS OF PROD CAN
BE IGNITED BY STATIC ELECTRICAL ENERGY.
RTECS #:9999999ZZ
Ingred Name:CNDTNS (STAB): PEROXIDE CMPDS WHEN EXPOS TO LIGHT/AIR.
THOUGH PROD CNTNS INHIBITORS TO PVNT PEROXIDE FORM, CARE (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7: SHOULD BE USED WHEN STORING THIS PROD OR HANDLING
OLD CNTNRS OF THIS MATL.
RTECS #:9999999ZZ
Ingred Name:FIRST AID: ARTF RESP TO SUPPORT VITAL FUNCS. REMOVE/COVER
GROSS CONTAM TO AVOID EXPOS TO RESCUERS. INGEST:CALL (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9: MD OR POIS CTL CTR FOR MOST CURRENT INFO. IF
PROFESSIONAL ADVICE IS NOT AVAIL, DO NOT INDUCE VOMIT. DRINK(ING
11)
RTECS #:9999999ZZ
Ingred Name:ING 10: MILK, EGG WHITES OR LG QTYS OF WATER. NEVER INDUCE
VOMIT/GIVE DILUENTS (MILK/WATER) IF UNCON, CONVULSING(ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11: OR UNABLE TO SWALLOW. TAKE CONTAM INDIVIDUAL FOR
MED ATTN ESP IF ADVERSE EFT OCCURS. TAKE RESCUERS FOR (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12: MED ATTN IF NEC. TAKE LABEL & MSDS W/VICTIM. RECOM
TO MD: TREAT SYMPS & ELIM OVEREXP. IF NEC, REVIEW (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13: FOR BRAIN & CNS EFTS & CONDUCT PULM FUNC TEST.
TESTS FOR LUNG, KIDNEY & LIVER EFTS MAY ALSO PROVE USEFUL.
RTECS #:9999999ZZ
Ingred Name:SPILL PROC:PERS PERMITTED IN AREA W/OUT LEVEL B PROT
RTECS #:9999999ZZ
Ingred Name:ING 15: & BOOTS, HARD-HAT & NIOSH APPRVD SCBA). PLACE
RESIDUE IN APPROP CNTNR & SEAL. CNTCT NEHC FOR MORE INFO .
RTECS #:9999999ZZ
Ingred Name:HNDLG/STOR: LIQS. POST "NO SMKNG" IN STOR & USE AREAS. USE
NON-SPKG TOOLS. BOND & GROUND DURING MATL TRANSFER. (ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17:STORE CNTNRS IN COOL, DRY LOCATION AWAY FROM DIRECT
SUN, SOURCES OF INTENSE HEAT/WHERE FREEZING IS POSS. (ING 19)
RTECS #:9999999ZZ
Ingred Name:ING 18: STORE MATL IN SECONDARY CNTNRS OR IN DIKED AREA AS
APPROP. STORE CNTNRS AWAY FROM INCOMPAT CHEMS. KEEP (ING 20)
RTECS #:9999999ZZ
Ingred Name:ING 19: CNTNR TIGHTLY CLSD WHEN NOT IN USE. STORAGE AREAS
SHOULD BE MADE OF FIRE-RESIST MATLS.
RTECS #:9999999ZZ
Ingred Name:OTHER PRECS: CNTNRS TO WELDING TORCHES OR ANY OTHER IGNIT
SOURCE. DURING MAINT OF CONTAM EQUIP:FOLLOW PRACTS (ING 22)
RTECS #:9999999ZZ
Ingred Name:ING 21: INDICATED. MAKE CERTAIN THAT APPLICATN EQUIP IS
LOCKED & TAGGED OUT SAFELY IF NEC. COLLECT ALL RINSATES (ING 23)
RTECS #:9999999ZZ
Ingred Name:ING 22: & DISPOSE OF ACCORDING TO APPLIC FED, STATE OR
LOCAL PROCEDURES.
RTECS #:9999999ZZ
Ingred Name:HYGIENE PRACTS: HNDLG THIS PROD. AVOID BRTHG VAPS/MISTS
GENERATED BY THIS PROD. USE IN WELL-VENTD LOCATION. (ING 25)
RTECS #:9999999ZZ
Ingred Name:ING 24: REMOVE CONTAMINATED CLTHG IMMEDIATELY.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENTS
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: OVEREXPS TO PROD CAN BE
IRRITATING TO EYES, SKIN & MUC MEMBS & CAN ALSO CAUSE CNS EFTS
(DIZZ, DROW, NAUS & HDCHS). INGEST OF PROD OR INHAL OF HIGH CONCS
OF PROD'S VAPS MAY BE FATAL. CHRONIC: PR LNGD/RPTD SKIN EXPOS CAN
LEAD TO DERMATITIS (DRYNESS, REDDENING & IRRIT OF SKIN).
TETRAHYDROFURAN, A (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: COMPONENT OF PROD, MAY CAUSE LIVER &
KIDNEY DAMAGE AFTER LONG-TERM INHAL OVEREXPS. THERE IS LIMITED
EVIDENCE FROM ANIMAL STUDIES THAT METHYL ETHYL KETONE IS A
REPRODUCTIVE TOXIN. TARGET ORGA NS: ACUTE: SKIN, EYES, RESPIRATORY
SYSTEM, CNS. CHRONIC: LIVER, KIDNEYS. CONTACT NEHC FOR MORE
DETAILED INFO .
Medical Cond Aggravated by Exposure:PREEXISTING RESPIRATORY PROBLEMS,
DERMATITIS AND OTHER SKIN DISORDERS, AS WELL AS CONDITIONS
INVOLVING THE "TARGET ORGANS" CAN BE AGGRAVATED BY EXPOSURE TO THIS
PRODUCT.
======================= First Aid Measures =======================
First Aid:SKIN: IMMED BEGIN DECONTAM W/RUNNING WATER. MINIMUM FLUSHING
IS FOR 15 MIN. REMOVE EXPOS/CONTAM CLTHG, TAKING CARE NOT TO CONTAM
EYES. SEEK MED ATTN IF ANY ADVERSE EFT OCCURS. EYES: OPEN VICTIM'S
EYES WHILE UNDER GENTLY RUNNING WATER. USE SUFFICIENT FORCE TO
OPEN EYELIDS. HAVE VICTIM "ROLL" EYES. MINIMUM FLUSHING IS FOR 15
MIN. SEEK IMMED MED ATTN. INHAL: REMOVE TO FRESH AIR. IF NEC, USE
(ING 9)
===================== Fire Fighting Measures =====================
Flash Point:15.8F,-9.0C
Lower Limits:SEE INGS
Upper Limits:SEE INGS
Extinguishing Media:WATER SPRAY (FOR COOLING ONLY), FOAM, HALON, CARBON
DIOXIDE, DRY CHEMICAL, ANY "B" CLASS.
Fire Fighting Procedures:USE NIOSH APPRVD SCBA & FULL PROT EQUIP .
INCIPIENT FIRE RESPONDERS SHOULD WEAR EYE PROT. IF IT IS SAFE TO DO
SO, ALLOW SM FIRES INVOLVING PROD TO(SUPDAT)
Unusual Fire/Explosion Hazard:THIS IS CLASS I-B FLAM LIQ. WHEN INVOLVED
IN FIRE, MATL MAY IGNITE & PRDCE IRRIT VAPS & TOX GASES (EG, CO,
CO*2). MATL WILL READILY IGNITE AT ROOM TEMP.(SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:ELIM ALL IGNIT SOURCES BEFORE CLEAN-UP. USE
NON-SPKG TOOLS. ABSORB SPILLED LIQ W/ACTIVATED
CARBON/POLYPADS/OTHER SUITABLE ABSORB MATLS. MONITOR AREA FOR
COMBUST VAPS & O*2 LEVEL. MONITORING MUST INDIC ATE <10% OF LEL &
>19.5% O*2 IN ATM BEFORE(ING 15)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:TRAIN EMPLOYEES TO HNDL MATL SAFELY.
PROPERLY LABEL CNTNRS. IF MIX IS USED IN OTHER TYPES OF CNTNRS,
ONLY USE PORTABLE CNTNRS APPRVD FOR FLAM (ING 17)
Other Precautions:INSPECT INCOMING CNTNRS BEFORE STOR TO ENSURE CNTNRS
PROPERLY LABELED & NOT DAMAGED. REFER TO NFPA 30, FLAM & COMBUST
LIQS CODE FOR ADDNL STOR INFO. EMPTY CNTNRS MAY CNTN RESIDUAL FLAM
LIQ/VAPS; HNDL W/CARE. DO NOT EXPOSE EMPTY (ING 21)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF RESP PROT IS NEEDED, USE ONLY NIOSH APPRVD
PROT AUTHORIZED IN 29 CFR 1910.134/APPLIC STATE REGS. USE SUPPLIED
AIR RESP PROT IF OXYG LEVELS ARE <19.5% OR UNKNOWN. CONTACT NEHC
FOR MORE INFO .
Ventilation:USE WITH ADEQUATE VENTILATION. MECHANICAL EXHAUST MAY BE
NEEDED.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER . USE
BODY PROTECTION APPROPRIATE FOR TASK (EG, APRON OR TYVEK SUIT).
Work Hygienic Practices:AVOID GETTING CHEMS ON/IN YOU. WASH THOROUGHLY
AFTER HNDLG. DO NOT EAT, DRINK, SMOKE/APPLY COSMETICS WHILE (ING
24)
Supplemental Safety and Health
FIRE FIGHT PROC: BURN OUT WHILE PROTECTING EXPOS. IF POSS, PVNT RUNOFF
WATER FROM ENTERING STORM DRAINS, BODIES OF WATER OR OTHER
ENVIRONMENTALLY SENSITIVE AREAS. IF NEC, RINSE CONTAM EQUIP
THOROUGHLYBEFORE RETURNING SUCH EQUIP TO SERVICE. EXPLO HAZ: VAPS
ARE HVR/AIR & MAY TRAVEL TO IGNIT SOURCE & FLASH BACK (ING 5)
================== Physical/Chemical Properties ==================
Spec Gravity:<1.0 (H*2O=1)
Evaporation Rate & Reference:>1 (NBUAC=1)
Solubility in Water:SOMEWHAT SOLUBLE
Appearance and Odor:CLEAR, PURPLE OR BLUE LIQUID; ETHEREAL ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
THIS PRODUCT WILL NOT BE COMPATIBLE WITH STRONG OXIDIZERS, LITHIUM
ALUMINUM HYDRIDE & ALKALINE EARTH HYDROXIDES.
Stability Condition to Avoid:EXPOS/CNTCT TO EXTREME TEMPS, IGNIT
SOURCES, INCOMPAT CHEMS. NOTE: TETRAHYDROFURAN CAN FORM POTNTLY
EXPLO (ING 7)
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE I/A/W APPROP FED, STATE & LOCAL
REGS. PROD, IF UNALTERED BY USE, MAY BE DISPOSED OF BY TREATMENT AT
PERMITTED FACILITY OR AS ADVISED BY LOCAL HAZ WASTE REGULATORY
AUTHORITY. US EPA WA STE NUMBER: D001 (CHARACTERIC/IGNITABILITY).
| 1 |
gloves_mandatory
|
=======================================================
NIIN: 00-458-9240
Product ID: CARBON DIOXIDE, GAS
Cage: 2W134
Box: 382
=======================================================
Contractor Summary
=======================================================
Cage: 1CU83
Box: 10606
Cage: 2W134
=======================================================
Item Description Information
=======================================================
Item Manager: S9I
Item Name: CARTRIDGE,INFLATOR,FLOTATION GEAR
Unit of Issue: EA
UI Container Qty: A
=======================================================
Ingredients
=======================================================
Cas: 124-38-9
RTECS #: FF6400000
% Wt: 100
Other REC Limits: NONE RECOMMENDED
OSHA PEL: 5000 PPM
ACGIH TLV: 5000PPM/30000STEL;96
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: NO
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: SIMPLE ASPHYXIANT. POISONING MAY AFFECT HEART, RESPIRATORY
AND NERVOUS SYSTEMS. SKIN CONTACT WITH LIQUIFIED GAS MAY CAUSE FROSTBITE.
EXPOSURE OF EYE TO HIGH CONCENTRATIONS OF GAS MAY CAUSE IRRITATION. IF
LIQUID IS SWALLOWED, FROSTBITE TO MOUTH & MUCOUS MEMBRANES MAY OCCUR.
Explanation Of Carcinogenicity: NONE OF THE INGREDIENTS IN THIS PRODUCT IS
LISTED BY NTP, IARC OR OSHA AS A CARCINOGEN.
Signs And Symptions Of Overexposure: INHALED-FAINT "ACIDIC" TASTE, HEADACHE,
DIZZINESS, SHORTNESS OF BREATH, MUSCULAR WEAKNESS, DROWSINESS, AND RINGING OF
THE EARS. SKIN (LIQUID CONTACT)-PAIN, HARD/WHITE SKIN, BLISTERS.
EYES-IRRITATION. STINGING. INGESTED (LIQUID CONTACT)-BURNS TO LIPS, MOUTH.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: EYES-FLUSH WITH WATER FOR 15 MINUTES. GET IMMEDIATE MEDICAL
ATTENTION. SKIN-IF FROSTBITE, WARM AFFECTED SKIN IN WARM WATER OR WARM TOWEL.
GET IMMEDIATE MEDICAL ATTENTION. INHALED-REMOVE TO FRESH AIR. ADMINISTER
OXYGEN OR ARTIFICIAL RESPIRATION AS NEEDED. MAINTAIN AIRWAY. GET IMMEDIATE
MEDICAL ATTENTION. INGESTED-TREAT SYMPTOMATICALLY AND GET MEDICAL ATTENTION.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: REMOVE PERSONNEL. VENTILATE AREA. WEAR SELF-
CONTAINED BREATHING APPARATUS. MOVE LEAKING CONTAINER OUTDOORS IF WITHOUT
RISK. SLOWLY RELEASE INTO ATMOSHPHERE. RETURN DEFECTIVE CYLINDER TO SUPPLIER.
TES T AREA FOR OXYGEN BEFORE ALLOWING RE-ENTRY.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: CONTACT YOUR LOCAL ENVIRONMENTAL OFFICER. RECOMMEND
VENTING SLOWLY TO ATMOSPHERE WITH ADEQUATE VENTILATIONS. DISPOSE OF IN
ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL REGULATIONS.
Handling And Storage Precautions: STORE IAW 29 CFR 1910.101. DO NOT PERMIT
PHYSICAL DAMAGE TO CYLINDER. CONTENTS UNDER PRESSURE; CYLINDERS MAY RUPTURE
AND TRAVEL FAR.
Other Precautions: CONTACT OF LIQUIFIED GASES WITH WATER MAY CAUSE EXPLOSIONS
DUE TO RAPID TEMPERATURE FLUCUATIONS. NEVER WORK ON A PRESSURIZED SYSTEM. IF
THERE IS A LEAK, CLOSE THE CYLINDER VALVE, BLOW DOWN SYSTEM BY V ENTING TO A
SAFE PLACE, THEN REPAIR LEAK
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: NONE
Extinguishing Media: USE HALON, WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures: WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A FULL
FACED SELF CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED CONTAINERS WITH
WATER SPRAY.
Unusual Fire/Explosion Hazard: CYLINDERS MAY EXPLODE IN HEAT OF FIRE. GAS
ITSELF HAS NEGLIDGIBLE FIRE HAZARD WHEN EXPOSED TO HEAT AND FLAME.
=======================================================
Control Measures
=======================================================
Respiratory Protection: IF ENGINEERING CONTROLS FAIL OR NON-ROUTINE USE OR AN
EMERGENCY OCCURS; WEAR AN MSHA/NIOSH AIR-SUPPLIED RESPIRATOR OR SCBA, AS
REQUIRED. USE IAW 29 CFR 1910.134.
Ventilation: USE ADEQUATE MECHANICAL VENTILATION OR LOCAL EXHAUST TO MAINTAIN
EXPOSURE BELOW TLV(S).
Other Protective Equipment: SAFETY SHOES. DO NOT WEAR CONTACT LENSES.
Work Hygienic Practices: WASH HANDS AFTER HANDLING AND BEFORE EATING, DRINKING,
OR SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health: CARBON DIOXIDE, BEING HEAVIER THAN AIR, TENDS
TO ACCUMULATE NEAR THE FLOOR OF AN ENCLOSED SPACE DISPLACING THE AIR AND
CREATING AN OXYGEN DEFFICIENT ATMOSPHERE. VENTILATE BEFORE ENTRY. VERIFY
SUFFICIE NT OXYGEN CONCENTRATION. RELEASING CO2 FROM THE CYLINDER CREATES DRY
ICE, WHICH MAY CAUSE FREEZE BURNS.
=======================================================
Physical/Chemical Properties
=======================================================
HCC: G3
B.P. Text: 109F,43C
M.P/F.P Text: -71F,-57C
Decomp Text: UNKNOWN
Vapor Pres: 43700
Vapor Density: 1.5
Spec Gravity: 1.52
PH: <7
Viscosity: UNKNOWN
Evaporation Rate & Reference: NONE SPECIFIED BY MFR.
Solubility in Water: APPRECIABLE
Appearance and Odor: CARTRIDGE, INFLATOR CONTAINING COLORLESS GAS.
Corrosion Rate: UNKNOWN
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: CONTACT OF LIQUIFIED GAS WITH WATER MAY CAUSE
EXPLOSION DUE TO RAPID TEMPERATURE FLUCUATIONS.
Materials To Avoid: ACRYLALDEHYDE,BARIUM PEROXIDE,METAL ACERYLIDES,METAL
HYDRIDES,METALS,POTASSIUM,POTASSIUM-SODIUM ALLOY,SODIUM PEROXIDE...
Hazardous Decomposition Products: TEMPERATURES ABOVE 1700C MAY CAUSE
DECOMPOSITION & THE RELEASE OF OXYGEN & HIGHLY TOXIC CARBON MONOXIDE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: HAZARDOUS POLYMERIZATION HAS NOT BEEN
REPORTED TO OCCUR UNDER NORMAL TEMPERATURES AND PRESSURES.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
Transportation Information
=======================================================
Trans ID NO: 72572
Product ID: CARBON DIOXIDE, GAS
Review Date: 08/21/1996
AF MMAC Code: NR
Multiple KIT Number: 0
Review IND: Y
Unit Of Issue: EA
Container QTY: A
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: CUX
DOT Proper Shipping Name: CARBON DIOXIDE
Hazard Class: 2.2
UN ID Num: UN1013
Label: NONFLAMMABLE GAS
Packaging Exception: 306
Non Bulk Pack: 302,304
Bulk Pack: 302,314,315
Max Qty Pass: 75 KG
Max Qty Cargo: 150 KG
Vessel Stow Req: A
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: DOH
IMO Proper Shipping Name: CARBON DIOXIDE
IMDG Page Number: 2111
UN Number: 1013
UN Hazard Class: 2(2.2)
IMO Packaging Group: -
Subsidiary Risk Label: -
EMS Number: 2-09
MED First Aid Guide NUM: 615
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: FHH
IATA UN ID Num: 1013
IATA Proper Shipping Name: CARBON DIOXIDE +
IATA UN Class: 2.2
IATA Label: NON-FLAMMABLE GAS
Packing Note Passenger: 200
Max Quant Pass: 75KG
Max Quant Cargo: 150KG
Packaging Note Cargo: 200
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: FHH
AFI Proper Shipping Name: CARBON DIOXIDE
AFI Hazard Class: 2.2
AFI UN ID NUM: UN1013
Special Provisions: P5
Back Pack Reference: A6.3,A6.5,A6.6
=======================================================
HAZCOM Label
=======================================================
Product ID: CARBON DIOXIDE, GAS
Cage: 2W134
Company Name: LELAND LTD INC
Street: 2614 S CLINTON AVE
Zipcode: 07080
Label Required IND: Y
Date Of Label Review: 08/21/1996
Status Code: C
Label Date: 08/21/1996
Origination Code: F
Signal Word: CAUTION
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: SIMPLE ASPHYXIANT. POISONING MAY AFFECT HEART,
RESPIRATORY AND NERVOUS SYSTEMS. SKIN CONTACT WITH LIQUIFIED GAS MAY CAUSE
FROSTBITE. EXPOSURE OF EYE TO HIGH CONCENTRATIONS OF GAS MAY CAUSE
IRRITATION. IF LIQUID IS SWALLOWED, FROSTBITE TO MOUTH & MUCOUS
MEMBRANES MAY OCCUR. FIRST AID: EYES-FLUSH WITH WATER FOR 15 MINUTES. GET
IMMEDIATE MEDICAL ATTENTION. SKIN-IF FROSTBITE, WARM AFFECTED SKIN IN WAR M
WATER OR WARM TOWEL. GET IMMEDIATE MEDICAL ATTENTION. INHALED-REMOVE TO
FRESHAIR. ADMINISTER OXYGEN OR ARTIFICIAL RESPIRATION AS NEEDED. MAINTAIN
AIRWAY. GET IMMEDIATE MEDICAL ATTENTION. INGESTED-TR EAT SYMPTOMATICALLY AND
GET MEDICAL ATTENTION.
=======================================================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:DETAPRIME BOOSTER, ST-1 PRIMERS
CAGE:HO930
CAGE:0E5W7
CAGE:HO930
============= Composition/Information on Ingredients =============
Ingred Name:PENTAERYTHRITOL TETRANITRATE
CAS:78-11-5
RTECS #:RZ2620000
Ingred Name:ACETYL TRIBUTYL CITRATE
CAS:77-90-7
Ingred Name:NITROCELLULOSE
CAS:9004-70-0
RTECS #:QW0970000
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:DETONATION MAY CAUSE SEV PHYSICAL
INJURY, INCL DEATH. THE PRODS HAVE NOT BEEN TESTED FOR TOX, BUT
BECAUSE OF THEIR PHYSICAL STATE, EXPOS TO TOX EFTS OF THE
COMPONENTS IS UNLIKELY. BASED ON KNOWN TOX O F COMPONENTS, ANTIC
HLTH EFTS FROM EXCESSIVE INHAL, SKIN/EYE CONT OR INGEST MAY INCL A
DROP IN BLOOD (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:PRESS, DECRD WEIGHT & DIARR. NITROGEN
OXIDES GENERATED DURING DETONATION ARE SKIN, EYE & RESP SYS IRRITS.
SYSTEMIC TOX RSLTG FROM OXIDATION OF LUNG TISS INCLS EMPHYSEMA,
BRONCH & BRONCHOPNEUM ONIA. ACUTE EXPOS CAN LEAD TO DEATH FROM
ASPHYXIA OR PULM EDEMA. IN ANIMALS, NITROGEN OXIDE CAUSED (SUPP
DATA)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:IF DETONATION FUMES INHALED, REMOVE TO FRESH AIR. IF
NOT BREATHING, GIVE ARTF RESP, PREFERABLY MOUTH-TO-MOUTH. IF
BREATHING IS DIFFICULT, GIVE OXYGEN. CALL MD. IF DETONATION CAUSES
PHYSICAL INJU RY, GET MEDICAL ATTENTION IMMEDIATELY.
===================== Fire Fighting Measures =====================
Extinguishing Media:DO NOT FIGHT FIRE! ISOLATE & EVACUATE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. DO NOT FIGHT FIRE. ISOLATE AREA. EVACUATE PERSONNEL TO SAFE AREA.
GUARD AGAINST INTRUDERS.
Unusual Fire/Explosion Hazard:CLASS A EXPLOS (DOT-USA). IN CANADA
CLASSIFICATION 1.1D. WILL DETONATE IF SUITABLY PRIMED W/SEV IMPACT
OR BY HEAT/FLAME. HAZ GASES PRDCED IN FIRE ARE (SUP DAT)
================== Accidental Release Measures ==================
Spill Release Procedures:REVIEW FIRE/EXPLOS HAZ & SFTY PRECS BEFORE
PROCEEDING W/CLEANUP. USE APPROP PERSONAL PROT EQUIP DURING
CLEANUP. REMOVE SOURCES OF HEAT, SPARKS, FLAME, IMPACT, FRICTION OR
ELECTRICITY. RECOVER UNDAMAGE D & MINIMALLY CONTAMD MATL FOR REUSE
OR(SUP DAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, WELL VENTD AREA. DO NOT
STORE W/OTHER EXPLOSIVES. STORE I/A/W NFPA & W/FED REGS. STORE IN
APPRVD TYPE MAGAZINE. USE ONLY W/ADEQ VENT.
Other Precautions:DO NOT STORE OR CONSUME FOOD, DRINK OR TOBACCO IN
AREAS WHERE THEY MAY BECOME CONTAMD W/THIS MATL. KEEP AWAY FROM
HEAT, SPARKS & FLAMES. CONSULT "ALWAYS' & NEVER'S" INSTRUCTIONS &
WARNINGS SUPPLIED W/ EACH PROD SHIPMENT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:USE ONLY W/ADEQUATE VENTILATION.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EXPLO HAZ:NITROGEN OXIDES. EFTS OF OVEREXP:METHEMOGLOBINEMIA, WAS NOT
CARCINOGENIC, BUT CAUSED EMBRYOTOXICITY & REPRODUCTIVE EFFECTS.
SPILL PROC:RECLAMATION. PICKUP BY HAND FOR DISPOSAL. DO NOT USE PO
WER EQUIPMENT. CONTROL ACCESS TO AREA. USE NON-SPARKING TOOLS.
================== Physical/Chemical Properties ==================
Spec Gravity:1.51 G/C @ 20C
Solubility in Water:INSOLUBLE
Appearance and Odor:RED OR WHITE RUBBER-LIKE TUBE; ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:NO
INCOMPATIBLE W/ACIDS, ALKALIES & OXIDANTS.
Stability Condition to Avoid:UNSTABLE W/HEAT, SHOCK & STATIC CHARGES.
Hazardous Decomposition Products:DECOMPOSES W/HEAT & SHOCK.
==================== Disposal Considerations ====================
Waste Disposal Methods:RECOVER FOR RECLAMATION. DO NOT BURN. CONSULT AN
EXPLOSIVE MANUFACTURER FOR RECOMMENDED METHODS OF DESTROYING
EXPLOSIVE MATERIALS. COMPLY W/APPICABLE FEDERAL, STATE/PROVINCE &
LOCAL REGULATIONS. DISPO SAL GOVERNED BY RCRA, 40 CFR 260-271 INTHE
U.S.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:PF DEGREASER SOLVENT
CAGE:0JVH6
CAGE:0JVH6
============= Composition/Information on Ingredients =============
Ingred Name:ALIPHATIC HYDROCARBON, TRADE SECRET REG #:80100071-5000P,
MONOCYCLIC TERPENE
CAS:68647-72-3
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 RAT,ORAL: >5G/KG OF BODY WT.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE:MAY CAUASE
IRRIT,TEARING,REDNESS.DONT INJURE EYE.SKIN:PROL/REP CONTACT MAY
CAUSE DEFATTING,DRYNESS.CONT DRYNESS MAY CAUSE DERM.INHAL:EXCESS
VAP INHAL CAN CAUSE IRRIT OF RESP TRACT,NAUSEA,DIZZ,HEAD
.INGEST:HAS LOW ORDER OF ACUTE ORAL TOXICITY BUT INGEST LG QUANT
MAY CAUSE NAU,VOMIT,GI IRRIT.MAY CAUSE INJURY(SUPPLEM)
Effects of Overexposure:EYE IRRIT,TEARING,REDNESS. DEFATTING,DRYNESS OF
SKIN, DERMATITIS. IRRIT OF RESP
TRACT,NAU,DIZZ,HEADACHE.NAU,VOMITING,GI IRRIT, INJURYT IF ASPIRATED
INTO LUNGS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH W/WTER FOR 15MINS.IRRIT PERSISTS CONTACT
PHYSICIAN.SKIN:WASH THOROUGHLY W/SOAP/WATER.REMOVE CONTAMIN
CLOTH.INHAL:IF AFFECTED BY VAP GET FRESH AIR.BREATH DIFFICULT SEE
PHYSICIAN.INGEST:DONT I NDUCE VOMIT.PRODUCT CONTAINS
HYDROCARBON.SEE PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:144F,62C
Autoignition Temp:Autoignition Temp Text:410F
Lower Limits:1.3
Upper Limits:8.9
Extinguishing Media:EXTINGUISH W/CO2, FOAM, OR DRY CHEMICAL. CLASS B
FIRE PROCEDURES.
Fire Fighting Procedures:EXTINGUISH W/CO2, FOAM, OR DRY CHEMICAL. CLASS
B FIRE PROCEDURES.
Unusual Fire/Explosion Hazard:COMBUSTIBLE LIQUID.CAN FORM COMBUSTIBLE
MIXTURES AT OR ABOVE FLASH POINT.
================== Accidental Release Measures ==================
Spill Release Procedures:LAND:REMOVE IGN SOURCES.CONTAIN SPILL.RECOVER
FREE PRODUCT.ABSORB W/SUITABLE CHEMC ABSORBENT FOR DISPO VIA
INCINERATION OR BURIAL IN APPROVED LANDFILL.OBSERVE LOC/STATE/FED
REGULATIONS.WATER:REMOVE BY SKIM/USE OF SUITABLE ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:ELECTROSTATIC ACCUMULATION
HAZ:UNKN,USE PROPER GROUNDING PROCEDURES.STORAGE TEMP:AMBIENT.KEEP
AWAY FROM HEAT SOURCES,OPN FLAMES,OTHER IGN SOURCES.
Other Precautions:KEEP OUT OF REACH OF CHILDREN.PHOTOCHEM REACTIVE MATL
PRESENT-YES,<10% BY VOL REACTIVE MATL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SPECIFIED BY MANUFACTURER.
Ventilation:NORMAL ROOM VENTILATION IS ADEQUATE.USE FANS OR OTHER
MECHANICAL VENTIALTION IN ENCLOSED AREAS WHERE LG PROD QUANT USED.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
HEALTH:IF ASPIRATED INTO LUNGS.
================== Physical/Chemical Properties ==================
HCC:V4
Boiling Pt:B.P. Text:380F,193C
Melt/Freeze Pt:M.P/F.P Text:NP
Decomp Temp:Decomp Text:NP
Vapor Pres:<1
Vapor Density:>1
Spec Gravity:0.76
pH:NA
Viscosity:NP
Evaporation Rate & Reference:3.2, N-BUTYL ACETATE=1.
Solubility in Water:NON-SOLUBLE.
Appearance and Odor:COLORLESS LIQUID WITH CHARACTERISTIC ODOR.
Percent Volatiles by Volume:100
Corrosion Rate:NP
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:KEEP AWAY FROM HEAT SOURCES,OPEN FLAMES &
OTHER IGNITION SOURCES.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
SMOKE.
==================== Disposal Considerations ====================
Waste Disposal Methods:CERCLA:NOT REPORTABLE.SARA TITLE III REPORTABLE
INGRED:NONE.INCINERATION OR BURINAL IN APPROVED LANDFILL.OBSERVE
LOC/STATE/FED REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:HI-BILD ALIPHATIC POLYURETHANE ENAMEL
CAGE:54636
CAGE:54636
============= Composition/Information on Ingredients =============
Ingred Name:ETHYL BENZENE
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: 5%
Other REC Limits:100 PPM
OSHA PEL:435 MG/CUM
ACGIH TLV:434 MG/CUM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:XYLENE, DIMETHYLBENZENE, XYLOL
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 29%
Other REC Limits:100 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM, SKIN
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:1,2,4-TRIMETHYLBENZENE
CAS:95-63-6
RTECS #:DC3325000
Fraction by Wt: 1%
OSHA PEL:25 PPM
ACGIH TLV:25 PPM
Ingred Name:HEXONE, METHYL ISOBUTYL KETONE (MIBK), 4-METHYL-2-PENTANONE
CAS:108-10-1
RTECS #:SA9275000
Fraction by Wt: 8%
Other REC Limits:50 PPM
OSHA PEL:100 PPM/75 STEL
ACGIH TLV:50 PPM/75 STEL; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TITANIUM DIOXIDE, TIO2
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 3%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:WEIGHT PER GALLON IN POUNDS: 8.29
RTECS #:9999999WG
Ingred Name:VOL ORGANIC CMPD: 3.86
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE, SKIN, OR RESPIRATORY IRRITANT.
NERVOUS SYSTEM DEPRESSION. EXTREME OVEREXPOSURE MAY CAUSE DEATH.
OVEREXPOSURE TO SOLVENTS MAY CAUSE PERMANENT BRAIN & NERVOUS SYSTEM
DAMAGE & ADVERSE EFFECTS TO THE LIVER, URINARY, BLOOD-FORMING,
CARDIO-VASCULAR & REPRODUCTIVE SYSTEMS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: HEADACHE, DIZZINESS, NAUSEA, LOSS
OF COORDINATION, UNCONSCIOUSNESS, DEATH. EYES/SKIN: REDNESS,
ITCHING OR BURNING SENSATION.
Medical Cond Aggravated by Exposure:SUSCEPTIBLE PERSONS OR
SENSITIZATION.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. KEEP WARM
& QUIET. SKIN: WASH W/SOAP & WATER. EYES: FLUSH W/PLENTY OF WATER
FOR 15 MINS. INGESTION: OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:60F
Lower Limits:0.7%
Upper Limits:6.7%
Extinguishing Media:CO2, DRY CHEMICAL, FOAM
Fire Fighting Procedures:USE FULL PROTECTIVE EQUIP & SCBA. WATER SPRAY
MAY BE INEFFECTIVE. IF WATER IS USED, FOG NOZZLES ARE PREFERABLE.
USE WATER TO COOL FIRE EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. APPLICATION TO HOT SURFACES REQUIRES
SPECIAL PRECAUTIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM IGNITION SOURCES.
DURING USE & UNTIL ALL VAPORS ARE GONE: KEEP AREA VENTILATED. DON'T
SMOKE. CONSULT NFPA CODE. DON'T TAKE INTERNALLY.
Other Precautions:EXTINGUISH ALL FLAMES, PILOT LIGHTS, & HEATERS. TURN
OFF STOVES, ELECTRIC TOOLS & APPLIANCES. USE APPROVED BONDING &
GROUNDING PROCEDURES. KEEP CONTAINER CLOSED WHEN NOT IN USE.
TRANSFER ONLY TO APPRO VED CONTAINERS W/COMPLETE LABELING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHERE OVERSPRAY IS PRESENT, USE A POSITIVE
PRESSURE AIR SUPPLIED RESPIRATOR (TC19C NIOSH/MSHA APPROVED). IF
UNAVAILABLE, USE A PROPERLY FITTED ORGANIC VAPOR/PARTICULATE
RESPIRATOR APPROVED BY NIOSH/MS HA. WEAR RESPIRATOR THE WHOLE TIME.
Ventilation:LOCAL EXHAUST: PREFERABLE. GENERAL EXHAUST: ACCEPTABLE IF
THE EXPOSURE TO HAZARDOUS INGREDIENTS IS KEPT BELOW TLV.
Other Protective Equipment:BARRIER CREAM ON EXPOSED SKIN
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH HANDS AFTER USING.
Supplemental Safety and Health
KEEP OUT OF REACH OF CHILDREN. THIS PRODUCT MUST BE MIXED W/OTHER
COMPONENTS BEFORE USE. BEFORE OPENING THE PACKAGES, READ & FOLLOW
WARNING LABELS ON ALL COMPONENTS. INTENTIONAL MISUSE BY
DELIBERATELY CONCENTRATING & INHALING THE CONTENTS CAN BE HARMFUL
OR FATAL. AVOID BREATHING VAPOR/SPRAY MIST & CONTACT W/SKIN/EYES.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:237-395F
Vapor Density:>1
Spec Gravity:0.96-1.21
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:55-60
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CONTAMINATION W/WATER, ALCOHOLS, AMINES & OTHER COMPOUNDS THAT MAY
REACT W/ISOCYANATES (POSSIBLE BURSTING).
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME OR OTHER IGNITION
SOURCES.
Hazardous Decomposition Products:BY FIRE: CO2, CO, OXIDES OF NITROGEN,
POSSIBILITY OF HYDROGEN CYANIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE MAY BE HAZARDOUS UNDER THE RCRA. TEST
WASTE FOR IGNITABILITY TO DETERMINE THE APPLICABLE EPA HAZARDOUS
WASTE NUMBERS. INCINERATE IN APPROVED FACILITY. DON'T INCINERATE
CLOSED CONTAINER. DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:TECHNIBRONZE PAPER
CAGE:51136
CAGE:51136
============= Composition/Information on Ingredients =============
Ingred Name:PAPER/FILM
Fraction by Wt: 95.0%
ACGIH TLV:NOT SPECIFIED
Ingred Name:PROPRIETARY COMPONENTS (ORGANIC)
Fraction by Wt: <5.0%
ACGIH TLV:NOT KNOWN
===================== Hazards Identification =====================
Effects of Overexposure:ACCORDING TO MFR,NO EFFECTS EXPECTED
======================= First Aid Measures =======================
First Aid:NONE REQUIRED.IF AT ALL NEEDED,USE NORMAL FIRST AIDS
PROCEDURES,CALL A PHYSICIAN IF NECESSARY.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER,CO*2,ALCOHOL FOAM,CHEMICAL POWDER.
Fire Fighting Procedures:COMBUSTION PRODUCTS MAY GIVE TOXIC GASES.USE
SCBA TO FIGHT F
Unusual Fire/Explosion Hazard:ON COMBUSTION OR AT HIGH TEMPERATURE
TOXIC GASES MAY BE PRODUCED.AVOID HIGH TEMPERATURES.
================== Accidental Release Measures ==================
Spill Release Procedures:USE NORMAL PROCEDURES.NO SPECIAL PROCEDURES
HAVE BEEN SUGGESTED BY THE MFR.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL DRY PLACE. PROVIDE
ADEQUATE VENTILATION.
Other Precautions:AVOID SKIN OR EYE CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED
Ventilation:MECH(GEN)OR LOCAL EXHAUST THAT PROVIDES ADEQUATE
VENTILATION
Other Protective Equipment:AS REQUIRED TO PREVENT PROLONGED CONTACT.
Supplemental Safety and Health
MSDS DATED 24,MAY 1982
================== Physical/Chemical Properties ==================
HCC:N1
Appearance and Odor:YELLOW COATED PAPER,NO ODOR
Percent Volatiles by Volume:UNKN
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:PRODUCTS OF COMBUSTION CO,CO*2 HCL.
==================== Disposal Considerations ====================
Waste Disposal Methods:PER MFR,LAND-FILL IS PREFERED METHOD,BUT FOLLOW
LOCAL STATE. FEDERAL REQULATIONS FOR DISPOSAL.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:VITA VMK-68 PORCELAIN
CAGE:67251
CAGE:67251
============= Composition/Information on Ingredients =============
Ingred Name:ALPHA-ALUMINA (ALUMINUM OXIDE) (EPA LISTS ONLY FIBROUS
FORMS) (SARA III)
CAS:1344-28-1
RTECS #:BD1200000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:BARIUM (SARA III)
CAS:7440-39-3
RTECS #:CQ8370000
OSHA PEL:0.5 MG/M3
ACGIH TLV:0.5 MG/M3; 9192
Ingred Name:BORON OXIDE
CAS:1303-86-2
RTECS #:ED7900000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3; 9293
Ingred Name:CALCIUM OXIDE
CAS:1305-78-8
RTECS #:EW3100000
OSHA PEL:5 MG/M3
ACGIH TLV:2 MG/M3; 9192
Ingred Name:MAGNESIUM OXIDE
CAS:1309-48-4
RTECS #:OM3850000
OSHA PEL:15 MG/M3 PARTICULATE
ACGIH TLV:10 MG/M3;TDUST; 9293
Ingred Name:SILICA, CRYSTALLINE - FUSED
CAS:60676-86-0
RTECS #:VV7328000
Other REC Limits:30 MG/CUM TOTAL DUST
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
Ingred Name:TIN
CAS:7440-31-5
RTECS #:XP7320000
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3; 9192
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:ZIRCONIUM
CAS:7440-67-7
RTECS #:ZH7070000
OSHA PEL:5 MG/M3/10 STEL
ACGIH TLV:5 MG/M3/10 STEL;9192
Ingred Name:CHROMIUM (SARA III)
CAS:7440-47-3
RTECS #:GB4200000
Fraction by Wt: <5%
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3; 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:COBALT (SARA III)
CAS:7440-48-4
RTECS #:GF8750000
Fraction by Wt: <5%
Other REC Limits:0.05 PPM
OSHA PEL:0.1 MG/M3;AS CO
ACGIH TLV:0.05 MG/M3;DUST 9293
Ingred Name:IRON OXIDE
CAS:1309-37-1
RTECS #:NO7400000
Fraction by Wt: <5%
OSHA PEL:10 MG/M3 (FE)
ACGIH TLV:5 MG/M3(FE),B2; 9293
Ingred Name:MANGANESE (SARA III)
CAS:7439-96-5
RTECS #:OO9275000
Fraction by Wt: <5%
OSHA PEL:(C) 5 MG/M3 DUST
ACGIH TLV:5 MG/M3 DUST 9293
Ingred Name:NICKEL (SARA III)
CAS:7440-02-0
RTECS #:QR5950000
Fraction by Wt: <5%
Other REC Limits:1 MG/CUM
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3; 9192
Ingred Name:VANADIUM (SARA III)
CAS:7440-62-2
RTECS #:YW1355000
Fraction by Wt: <5%
OSHA PEL:C,0.5 MG V2O5/M3 RD
ACGIH TLV:0.05 MG V205/M3;9293
Ingred Name:ZINC OXIDE
CAS:1314-13-2
RTECS #:ZH4810000
Fraction by Wt: <5%
OSHA PEL:15MG/M3 TDUST/5 FUME
ACGIH TLV:10MG/M3 TDUST; 9293
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHALATION: IRRITATION.
Explanation of Carcinogenicity:SILICA, CHROMIC OXIDE, & NICKEL OXIDE
ARE SUSPECTED A1 CARCINOGENS.
Effects of Overexposure:INHALATION: IRRITATION.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. OBTAIN MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP SPILLED MATERIAL.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID INHALATION OF CERAMIC DUST.
AVOID LICKING CERAMIC APPLICATION BRUSH.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NUISANCE DUST MASK IS RECOMMENDED WHILE GRINDING
FIRED PORCELAIN.
Ventilation:MECHANICAL EXHAUST VENTILATION IS RECOMMENDED WHILE
GRINDING FIRED PORCELAIN.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>2192F
Melt/Freeze Pt:M.P/F.P Text:1760F
Solubility in Water:INSOLUBLE
Appearance and Odor:WHITE OR LIGHT PASTEL COLORED PORCELAIN POWDER W/NO
ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CONCENTRATED HYDROFLUORIC ACID
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE AS SOLID WASTE IN ACCORDANCE W/LOCAL,
STATE, & FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:6859 NAVAJO WHITE COLOR SHADES LATEX SEMI-GLOSS
CAGE:EO698
CAGE:01PD6
CAGE:EO698
============= Composition/Information on Ingredients =============
Ingred Name:CLAY (KAOLIN), ALUMINUM SILICATE *98-2*
CAS:1332-58-7
RTECS #:GF1670500
Fraction by Wt: 5-10%
ACGIH TLV:10 MG/CUM TOTAL DUST
Ingred Name:PROPANOIC ACID, 2-METHYL, MONOESTER
W/2,2,4-TRIMETHYL-1,3-PENTANEDIOL, TEXANOL(ESTER ALCOHOL)
CAS:25265-77-4
RTECS #:UF6000000
Fraction by Wt: 1-5%
Ingred Name:TITANIUM DIOXIDE, TITANIUM OXIDE (SUSPECTED ANIMAL
CARCINOGEN, IARC GROUP 3)*98-2*
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 10-20%
OSHA PEL:15 MG/CUM
ACGIH TLV:10 MG/CUM (DUST)
Ingred Name:VINYL ACRYLIC RESIN *98-2*
CAS:25067-01-0
Fraction by Wt: 10-20%
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 10-50%
Ingred Name:VOLATILE ORGANIC CONTENT: 9.90 WT/GAL; 86.28 G/L
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: RESPIRATORY/MUCOUS
MEMBRANE IRRITANT. CNS DEPRESSION. MAY CAUSE ANESTHETIC EFFECTS;
BLOOD ABNORMALITIES, KIDNEY DAMAGE, PNEUMOCONIOSIS. SKIN:
IRRITATION/DERMATITIS/ABSORPTION. EYES: IRRITA TION. INGESTION: MAY
CAUSE DAMAGE TO LIVER/KIDNEY/BRAIN, PULMONARY EDEMA,
CARDIAC/RESPIRATORY FAILURE/DEATH.
Explanation of Carcinogenicity:NONE
Effects of
Overexposure:IRRITATION/DROWSINESS/DIZZINESS/LIGHTHEADEDNESS/HEADAC
HE/GI DISTURBANCES/COUGHING/SNEEZING/APATHY/NARCOSIS/LOSS OF
CONSCIOUSNESS/VOMITING/DIARRHEA/ABDOMINAL PAIN/RESPIRATORY
PROBLEMS/INTOXICATION/RESP IRATORY, CARDIAC FAILURE.
Medical Cond Aggravated by Exposure:EYE, SKIN, RESPIRATORY DISORDERS,
KIDNEY DISORDERS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE & SUPPORT CONTINUED
BREATHING. HAVE TRAINED PERSON GIVE OXYGEN IF NEEDED. SKIN: FLUSH
W/WATER, THEN WASH THOROUGHLY W/SOAP & WATER. EYES: FLUSH
IMMEDIATELY W/L ARGE AMOUNTS OF WATER FOR 15 MINS. OBTAIN MEDICAL
ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:NONE
Extinguishing Media:DRY CHEMICAL/FOAM, WATER FOG, CO2
Fire Fighting Procedures:WATER MAY BE USED TO COOL & PROTECT EXPOSED
CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT/FIRE. VAPORS ARE >AIR & MAY TRAVEL LONG
DISTANCES TO AN IGNITION SOURCE & FLASHBACK. (SEE SUPP)
================== Accidental Release Measures ==================
Spill Release Procedures:EIMINATE IGNITION SOURCES. VENTILATE/EVACUATE
AREA. PLACE COLLECTED MATERIAL IN PROPER CONTAINER. LARGE: SHUT OFF
LEAK SAFELY. DIKE/CONTAIN MATERIAL. PUMP TO STORAGE/SALVAGE
VESSELS. KEEP SALVAGEABLE MATERIAL & RINSE WATER OUT OF
SEWERS/WATERCOURSES.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE BELOW 100F. KEEP AWAY FROM
IGNITION SOURCES. KEEP OUT OF REACH OF CHILDREN. KEEP CONTAINERS
TIGHTLY CLOSED & UPRIGHT WHEN NOT IN USE.
Other Precautions:KEEP FROM FREEZING. DON'T TAKE INTERNALLY. AVOID
CONTACT W/SKIN & EYES & BREATHING OF VAPORS. AVOID CONDITIONS WHICH
RESULT IN FORMATION OF INHALABLE PARTICLES SUCH AS
SPRAYING/ABRADING PAINTED SURFAC ES. USE PROPER RESPIRATORY
PROTECTION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE ONLY NIOSH/MSHA APPROVED RESPIRATORS
IAW/OSHA STANDARD 29 CFR 1910.134.
Ventilation:DILUTION VENTILATION/LOCAL EXHAUST TO PREVENT BUILDUP OF
VAPORS.
Other Protective Equipment:IMPERVIOUS CLOTHING, EYE WASH, SAFETY SHOWER
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH HANDS THOROUGHLY AFTER HANDLING, BEFORE EATING/SMOKING.
Supplemental Safety and Health
FIRE HAZ CONT'D: VAPORS CAN FORM EXPLOSIVE MIXTURES IN AIR AT ELEVATED
TEMPS. IN CLOSED TANKS, WATER/FOAM MAY CAUSE FROTHING/ERUPTION.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212-477F
Appearance and Odor:NAVAJO WHITE
Percent Volatiles by Volume:71.83
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS, ACIDS, REDUCING AGENTS, ALUMIUM, ZINC, METALS, NITRIC ACID,
HYDROFLUORIC ACID, MAGNESIUM, SODIUM, POTASSIUM.
Stability Condition to Avoid:EXTREME HEAT/FIRE, ELEVATED TEMPS, SPARKS,
OPEN FLAMES, FREEZING
Hazardous Decomposition Products:CO, CO2, OXYGEN, TOXIC GASES,
PROPIONALDEHYDE
==================== Disposal Considerations ====================
Waste Disposal Methods:AVOID DISCHARGE TO NATURAL WATERS. DISPOSE OF IN
ACCORDANCE W/LOCAL, STATE & FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:DILUTE HYDROCHLORIC ACID (1+3)
Preparer's Name:PJ MALONEY
CAGE:86035
CAGE:86035
============= Composition/Information on Ingredients =============
Ingred Name:HYDROGEN CHLORIDE (HYDROCHLORIC ACID) (SARA 302/313)
(CERCLA)
CAS:7647-01-0
RTECS #:MW4025000
Fraction by Wt: 11%
OSHA PEL:C 5 PPM
ACGIH TLV:C 5 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:SUP DAT: RPTD FOR 50 DAYS CAUSED ONLY SLIGHT UNREST & IRRIT
OF EYES & NOSE OF RABBITS, GUINEA PIGS & PIDGEONS. (ING 3)
RTECS #:9999999ZZ
Ingred Name:ING 2: THE HEMOGLOBIN CONTENT OF THE BLOOD WAS ONLY
SLIGHTLY DIMINISHED.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC: SEEK MEDICAL AID. OBSERVE FOR POSSIBLE
DELAYED REACTION.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYE: MAY CAUSE IRRIVERSIBLE EYE
DMG UPON CONT DEPENDING ON LENGTH OF EXPOS, SOLN CONC & FIRST AID
MEASURES. SKIN: MAY CAUSE IRRIT UPON CONT. DERM & PHOTOSENSIT MAY
RSLT FROM INDUS CONT W/HYDROC HLORIC ACID. INGEST: MAY CAUSE SEV
IRRIT/BURNS OF MUC MEMB OF MOUTH, THROAT, ESOPHAGUS & STOM. (EFTS
OF OVEREXPOSURE)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: INHAL: MIST/VAP MAY CAUSE COUGHING &
CHOKING DUE TO IRRIT OF RESP TRACT. HYDROGEN CHLORIDE VAPS ARE
EXTREMELY IRRIT TO RESP TRACT & MAY CAUSE BRTHG DFCLTY. IRRITANT
EFT OF HYDROGEN CHLORIDE VAPS ON RESP TRACT MAY PRDCE LARYNGITIS,
GLOTTAL EDEMA & BRONCH. CHRONIC: WORKERS EXPOSED TO HYDROCHLORIC
(SUP DAT)
Medical Cond Aggravated by Exposure:PREEXISTING SKIN AND RESPIRATORY
CONDITIONS.
======================= First Aid Measures =======================
First Aid:EYES: IMMED FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MIN. SEEK
MED AID IMMED. SKIN: FLUSH W/PLENTY OF WATER. REMOVE CONTAM CLTHG.
SEEK MED AID IF IRRIT PERSISTS. WASH CLTHG BEFORE REUSE. INGEST:
GIVE L UKEWARM WATER/MILK IF COMPLETELY ALERT.DO NOT INDUCE VOMIT
BECAUSE OF CORR EFTS. OBTAIN EMER MED ATTN. INHAL: REMOVE TO FRESH
AIR. IF NOT BRTHG GIVE ARTF RESP. IF BRTHG IS DFCLT GIVE OXYGEN.
(ING 4)
===================== Fire Fighting Measures =====================
Flash Point:>250F,>121C
Extinguishing Media:USE WATER, CARBON DIOXIDE, OR DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. EXERCISE CAUTION WHEN FIGHTING ANY CHEM FIRE. NEUT W/LIME, SODA
ASH, ETC, TO PVNT CORR OF METALS (SUP DAT)
Unusual Fire/Explosion Hazard:CONT W/SOME METALS CAN GENERATE FLAM
HYDROGEN GAS. PROD EMITS TOX GASES UNDER FIRE CNDTNS. RUNOFF FROM
FIRE CTL/DILUTION WATER MAY CAUSE POLLUTION. (SUP DAT)
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA OF SPILL. WEARING APPROPRIATE
PERSONAL PROTECTIVE EQUIPMENT, CONTAIN SPILL, COLLECT ONTO INERT
ABSORBENT AND PLACE INTO SUITABLE CONTAINER.
Neutralizing Agent:MAY BE NEUTRALIZED CAREFULY W/WEAK CAUSTIC
SOLNS/SODIUM CARBONATE.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT GET IN EYES. AVOID BREATHING
VAPOR OR MIST. AVOID CONTACT WITH SKIN AND CLOTHING. USE WITH
ADEQUATE VENTILATION.
Other Precautions:KEEP CONTR CLSD WHEN NOT IN USE. STORE IN COOL,
WELL-VENTILATED AREA AWAY FROM INCOMPATIBLE MATLS. PROD SHOULD BE
STORED IN GLASS, STEEL, PLASTIC/EPOXY-LINED VESSELS. DO NOT USE
W/ALUMINUM/COPPER STOR /FEED SYSTEMS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF AIRBORNE CONCENTRATIONS EXCEED PUBLISHED
EXPOSURE LIMITS, USE A NIOSH/MSHA APPROVED RESPIRATOR IN ACCORDANCE
WITH OSHA RESPIRATORY PROTECTION REQUIREMENTS (29 CFR 1910.134).
Ventilation:LOCAL EXHAUST VENT MAY BE REQUIRED IN ADDITION TO GENERAL
ROOM VENT TO MAINTAIN AIRBORNE CONCS BELOW EXPOSURE LIMITS.
Other Protective Equipment:EMERGENCY EYEWASH & DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA .
Work Hygienic Practices:WASH THORO AFTER HNDLG. PROT EQUIP SHOULD BE
CLEANED THORO AFTER EACH USE. CONTACT LENSES MUST NOT BE WORN.
Supplemental Safety and Health
FIRE FIGHT PROC: & FORM OF HYDROGEN. EXPLO HAZ: CLSD CONTRS MAY RUPTURE
DUE TO PRESS BUILDUP WHEN EXPOSED TO EXTREME HEAT. EFTS OF OVEREXP:
ACID HAVE SUFFERED FROM GASTRITIS & CHRONIC BRONCH. PRLNG EX POS TO
HCL GAS AT LOW CONCS CAUSES EROSION OF TEETH. IN ANIMAL TESTS
W/HCL, EXPOS OF 6 HRS DAILY AT 100 PPM (ING 2)
================== Physical/Chemical Properties ==================
Spec Gravity:1.05
pH:<1.0
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, COLORLESS LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALUMINUM, COPPER, MILD STEEL, BRASS, ZINC, GALVANIZED MATERIALS, BASES,
OXIDIZERS.
Stability Condition to Avoid:OVERHEATING.
Hazardous Decomposition Products:HYDROGEN CHLORIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCARDED PROD, AS SOLD, WOULD BE CONSIDERED
RCRA HAZ WASTE BASED ON CHARACT OF CORROSIVITY. EPA HAZ WASTE # IS
D002. DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS. KEEP FROM ENTE RING STREAMS OR LAKES.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:AUTOLINE FLEXC MOTOR OIL, GRADE 10
CAGE:KO038
CAGE:04957
CAGE:KO038
============= Composition/Information on Ingredients =============
Ingred Name:BASE STOCK
Fraction by Wt: 89%
Ingred Name:LUBRIZOL 4801
Fraction by Wt: 11%
===================== Hazards Identification =====================
Effects of Overexposure:PROLONGED/FREQUENT EXPOSURE CAN CAUSE MINOR
SKIN/EYE IRRIT
======================= First Aid Measures =======================
First Aid:SKIN: WASH THOROUGHLY W/MILD SOAP & WATER. EYE: IMMED FLUSH
W/WATER AT LEAST 15 MIN, CALL MD.
===================== Fire Fighting Measures =====================
Flash Point:450F COC
Extinguishing Media:CO*2, DRY CHEM, FOAM, WATER SPRAY
Fire Fighting Procedures:USE SELF-CNTND BRTHNG APPARATUS & PROPER PROT
EQUIP
================== Accidental Release Measures ==================
Spill Release Procedures:USE OIL ABSORBENT OR OTHER MEDIUM TO CLEAN &
ABSORB OIL
======================Handling and Storage ======================
Handling and Storage Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE
Ventilation:NONE
Supplemental Safety and Health
SOLUBILITY IN WATER:POOR. PRODUCT IS ALSO QUALIFIED UNDER MIL-L-46152 &
MIL-L-45199
================== Physical/Chemical Properties ==================
HCC:V6
Boiling Pt:B.P. Text:685-1000F
Spec Gravity:0.88
Appearance and Odor:PETROLEUM MOTOR OIL, DARK
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE OR PROPER DISPOSAL AREA, MFR. DISPOSE
IAW LOCAL, STATE, FED REG.
| 0 |
gloves_not_mandatory
|
===================== Product Identification =====================
Product ID:HYDRAZINE
CAGE:LO772
CAGE:LO772
CAGE:5G937
============= Composition/Information on Ingredients =============
Ingred Name:HYDRAZINE
CAS:302-01-2
RTECS #:MU7175000
Fraction by Wt: 22%
OSHA PEL:S, 1 PPM
ACGIH TLV:S, 0.1 PPM, A2; 9293
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: DIZZINESS, NAUSEA, IRRITATION
TO SKIN & EYES, MUCOUS MEMBRANE. CHRONIC: CNS DEPRESSION: TEMPORARY
BLINDNESS, DAMAGE TO LIVER, ETC.
Explanation of Carcinogenicity:HYDRAZINE: ANTICIPATED TO BE A
CARCINOGEN(NTP), GROUP 2B(IARC).
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:CONTACT PHYS IN ANY CASES OF PROLONGED IRRITATION, NAUSEA,
ETC. SKIN: FLUSH WITH WATER. INGEST: DO NOT INDUCE VOMIT; DILUTE
W/H*2O. EYES: IMMED FLUSH WITH POTABLE WATER FOR A MINIMUM OF 15
MIN, SEEK A SSISTANCE FROM MD . INHAL: REMOVETO FRESH AIR.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:>200F,>93C
Extinguishing Media:WATER.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:SOLUTIONS CONCENTRATED BY FIRE MAY BECOME
EXPLOSIVE.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION, WEAR
NIOSH/MSHA APPROVED SCBA. WEAR TOTAL PROTECTIVE/IMPERVIOUS SUIT,
NEUTRALIZE AND DISPOSE OF.
Neutralizing Agent:DILUTE HYPOCHLORITE SOLUTION.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONT W/SKIN/EYES/CLTH. DO NOT
BREATHE VAP. DESTROY CONTAM LEATHER GOODS. STORE IN WELL VENTD AREA
AWAY FROM OXIDIZERS & ACIDS. AVOID HIGH TEMP.
Other Precautions:USE THE GREATEST CARE IN HANDLING THIS OR ANY OTHER
SUSPECTED CARCINOGENIC MATERIAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:AS REQUIRED TO KEEP HYDRAZINE CONCENTRATION BELOW TLV.
Other Protective Equipment:AVOID SKIN CONTACT WITH ANY IMPERVIOUS SUIT.
EMERGENCY EYEWASH, DELUGE SLOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:229F,110C
Melt/Freeze Pt:M.P/F.P Text:-87F,-66C
Spec Gravity:1.013(H*2O=1)
Solubility in Water:100%
Appearance and Odor:COLORLESS/AMINE ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
O*2, OXIDANTS, METAL OXIDES, METAL SALT.
Stability Condition to Avoid:CONCENTRATION BY EVAPORATION.
Hazardous Decomposition Products:AMMONIA & NITROGEN OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:FOLLOW LOCAL, STATE AND FEDERAL REGULATIONS.
CONTACT HAZARDOUS WASTE DISPOSAL SERVICE IN CASE OF EMERGENCY.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:DIESEL FUELS
Preparer's Name:ENVIRONMENTAL HEALTH & SA
CAGE:57635
CAGE:57635
CAGE:3V728
============= Composition/Information on Ingredients =============
Ingred Name:DIESEL FUEL
CAS:68334-30-5
RTECS #:HZ1800000
Fraction by Wt: 100%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: HARMFUL IF IN CONTACT WITH OR
ABSORBED THROUGH THE SKIN. CONTACT MAY CAUSE SKIN AND EYE
IRRITATION. INHALATION IS MODERATLEY TOXIC. INGESTION IS SLIGHTLY
TOXIC. CHRONIC: PROLONGED OR REPEATED E XPOSURE MAY CAUSE LIVER OR
BLOOD-FORMING ORGAN DAMAGE, EFFECT THE UNBORN. MAY CAUSE SKIN
IRRITATION OR DERMATITIS.
Explanation of Carcinogenicity:PER MANUFACTURER'S MSDS-ANIMAL STUDIES
SHOW DIESEL EXHAUST HAS THE POTENTIAL FOR LUNG CANCER.
Effects of Overexposure:SKIN/EYE-DRY SKIN, IRRITATION. INHALED:
RESPIRATORY IRRITATION, DIZZINESS, NAUSEA, LOSS OF CONSCIOUSNESS.
INGESTION-NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES-FLUSH WITH WATER. GET MEDICAL ASSISTANCE. SKIN-DRY WIPE.
WASH WITH WATERLESS CLEANER, FOLLOWED BY SOAP & WATER. REMOVE
CONTAMINATED CLOTHES & SHOES. INHALED-REMOVE FROM EXPOSURE. IF
UNCONSCIOUSNE SS OCCURS, SEEK IMMEDIATE MEDICAL ASSISTANCE. IF
BREATHING STOPPED, GIVE ARTIFICIAL RESPIRATION. INGESTED-DO NOT
INDUCE VOMITING! IF CONSCIOUS, GIVE 1-2 GLASSES OF WATER. GET
IMMEDIATE MEDICAL HELP.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>100F,>38C
Extinguishing Media:WATER FOG, CARBON DIXOIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:FIREFIGHTERS SHOULD WEAR FULL PROTECTIVE
CLOTHING INCLUDING SELF-CONTAINED BREATHING APPARATUS. USE WATER TO
COOL FIRE EXPOSED CONTAINERS. CONTAIN RUNOFF.
Unusual Fire/Explosion Hazard:MATERIAL IS COMBUSTIBLE.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB ON FIRE RETARDANT TREATED SAWDUST,
DIATOMACEOUS EARTH, ETC. SHOVEL UP AND DISPOSE OF IN ACCORDANCE
WITH CURRENT LOCAL, STATE AND FEDERAL REGULATIONS. REPORT SPILLS AS
REQUIRED TO PROPER AUTHORI TIES. IF AFFECTS WATERWAYS-CALL
800-424-8802.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE AWAY FROM
SOURCES OF IGNITION AND INCOMPATIBLE MATERIALS. AVOID ALL PERSONAL
CONTACT AND BREATHING MISTS/VAPORS.
Other Precautions:FLAMMABLE ATMOSPHERE CAN BE PRODUCED IN TANKS. GROUND
& BOND ALL TRANSFER EQUIPMENT. STORED MATERIAL MUST BE LABELED AS
COMBUSTIBLE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NO SPECIAL REQUIREMENTS UNDER NORMAL CONDITIONS
OF USE AND WITH ADEQUATE VENTILATION.
Ventilation:VENTILATION DESIRABLE AND EQUIPMENT MUST BE
EXPLOSION-PROOF. USE IN WELL-VENTILATED AREA.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER. DLA-HMIS:
EYE WASH STATION & SAFETY SHOWER AVAILABLE FOR EMERGENCIES.
Work Hygienic Practices:WASH HANDS AFTER USE AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health
ENVIRONMENTAL DATA: SARA 311/312-FIRE, CHRONIC, ACUTE; SARA 313: NONE.
TSCA-ALL. NOTE: THIS PRODUCT CONTAINS AROMATIC OILS WHICH CONTAIN
POLYCYCLIC AROMATIC HYDROCARBONS (PCAH). UNDER CONDITIONS OF PO OR
PERSONAL HYGIENE SOME PCAH MAY CAUSEHUMAN SKIN CANCER. MD'S NOTE:
ASPIRATED PRODUCT MAY CAUSE CHEMICAL PNEUMONITIS.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:350F,177C
Vapor Pres:0.5 MM HG
Spec Gravity:0.82-0.87
Viscosity:1.3-4.1 CST
Appearance and Odor:CLEAR TO AMBER LIQUID; HYDROCARBON ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
HALOGENS, STRONG ACIDS, ALKALIS AND OXIDIZERS.
Stability Condition to Avoid:HEAT, SPRAKS, FLAME, AND BUILD-UP OF
STATIC ELECTRICITY. DLA-HMIS: AVOID CONTACT WITH INCOMPATIBLE
MATERIALS.
Hazardous Decomposition Products:CARBON MONOXIDE FROM INCOMPLETE
COMBUSTION.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:PRODUCT IS SUITABLE FOR BURNING AS FUEL VALUE IN
COMPLIANCE WITH APPLICABLE LOCAL, STATE AND FEDERAL REGULATIONS.
EPA/RCRA HAZARDOUS WASTE NUMBER D001 (IGNITABLE) (FLASHPOINT <140F)
MAY APPLY TO UNUSE D/UNCONTAMINATED PRODUCT.
| 1 |
gloves_mandatory
|
=======================================================
Product ID: IJD-226 MAGENTA
Cage: 6D656
Box: 483070
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 3D656
Box: 1056
Cage: 6D656
Box: 483070
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: NO
Skin: NO
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: INHAL: CONSIDERED TO BE RELATIVELY NONTOXIC.
SKIN/EYE/INGEST: NONE EXPECTED.
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: EYE: FLUSH THOROUGHLY W/WATER. SEEK MED ATTN IF IRRITATION PERSISTS.
SKIN: WASH CONTAMD AREAS W/SOAP & WATER. INHAL: REMOVE TO FRESH AIR.
SUPPORT BREATHING(GIVE O*2/ARTF RESP)(FP N). INGEST: INDUCE VO MITING AND
CALL A DOCTOR.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: SOAK UP ON PAPER OR OTHER ABSORBANT AND SCOOP INTO
CLOSED CONTAINERS. FLUSH AREA WITH PLENTY OF WATER.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: REMOVE TO AN APPROVED LANDFILL SITE OR INCINERATOR.
DISPOSE OF IN ACCORDANCE W/LOCAL, STATE & FEDERAL REGULATIONS.
Handling And Storage Precautions: STORE AT ROOM TEMPERATURE.
Other Precautions: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Extinguishing Media: USE MEDIA SUITABLE FOR SURROUNDING FIRE(FP N).
Fire Fighting Procedures: WEAR NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT(FP N).
Unusual Fire/Explosion Hazard: NONE KNOWN.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NOT NECESSARY(MFR). USE NIOSH/MSHA APPROVED RESPIRATOR
APPROPRIATE FOR EXPOSURE OF CONCERN(FP N).
Ventilation: MECHANICAL VENTILATION ACCEPTABLE.
Other Protective Equipment: EMERGENCY EYEWASH & DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA(FP N). IMPERVIOUS CLTHG WHERE SKIN CONT IS UNAVOIDABLE.
Work Hygienic Practices: AVOID CONTAMINATION OF FOOD, DRINK, ETC.
Supplemental Safety and Health: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: 212F,100C
Vapor Pres: 17.5
Vapor Density: HVR/AIR
Spec Gravity: 1.074(H*2O=1)
Evaporation Rate & Reference: >1 (BUAC=1)
Solubility in Water: COMPLETE
Appearance and Odor: RED LIQUID; MILD ODOR.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE KNOWN.
Materials To Avoid: OXIDIZING MATERIALS.
Hazardous Decomposition Products: NONE KNOWN.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: IJD-226 MAGENTA
Cage: 6D656
Company Name: FORMULABS, INC
Street: 529 WEST FOURTH AVE
PO Box: 483070
Zipcode: 92025
Label Required IND: Y
Date Of Label Review: 09/15/1995
Status Code: C
Label Date: 09/15/1995
Origination Code: G
Skin Protection IND: YES
Signal Word: NONE
Respiratory Protection IND: YES
Health Hazard: None
Contact Hazard: None
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE: INHALATION: CONSIDERED TO BE RELATIVELY
NONTOXIC. SKIN/EYE/INGESTION: NONE EXPECTED. CHRONIC: NONE SPECIFIED BY
MANUFACTURER.
=======================================================
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:478612 CERTAIN THB CO-OXIMETRY CONTROL
CAGE:51404
CAGE:51404
============= Composition/Information on Ingredients =============
Ingred Name:THIMEROSAL, ETHYLMERCURITHIOSALICYCIC ACID, SODIUM SOLUTION
CAS:54-64-8
RTECS #:OV8400000
Fraction by Wt: <0.2%
OSHA PEL:0.01 MG/CUM
ACGIH TLV:0.1 MG/CUM
Ingred Name:BOVINE HEMOGLOBIN
Fraction by Wt: <0.2%
Ingred Name:INERT INGREDIENTS (TYPE NOT SPECIFIED)
Fraction by Wt: <0.2%
Ingred Name:PRESERVATIVES, TYPE NOT SPECIFIED
Fraction by Wt: <0.2%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN & EYE IRRITATION.
Explanation of Carcinogenicity:NONE
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/PLENTY OF WATER. SKIN: WASH W/SOAP & WATER.
OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE EXTINGUISHING MEDIA APPROPRIATE FOR SURROUNDING
FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:MOP UP AFFECTED AREA. RINSE W/WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID HIGH TEMPERATURES & KEEP FROM
FREEZING.
============= Exposure Controls/Personal Protection =============
Other Protective Equipment:LABORATORY PROTECTIVE CLOTHING
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:100C
Melt/Freeze Pt:M.P/F.P Text:0C
Spec Gravity:2
Solubility in Water:COMPLETE
Appearance and Odor:RED ODORLESS LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HIGH TEMPERATURES & FREEZING
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:HOBART 10 AWS A5.1 CLASS E6010
CAGE:28835
CAGE:28835
============= Composition/Information on Ingredients =============
Ingred Name:FERRO MANGANESE
CAS:12604-53-4
RTECS #:OO9286520
Fraction by Wt: 6%
Other REC Limits:NONE
OSHA PEL:1MG/M*3(MN FUMES)
ACGIH TLV:1MG/M*3(MN FUMES)
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 30%
Other REC Limits:NONE
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:SODIUM SILICATE
CAS:6834-92-0
RTECS #:VV9275000
Fraction by Wt: 45%
Other REC Limits:NONE
OSHA PEL:80MG/M*3(AMORPHOUS)
ACGIH TLV:10MG/M*3(AMORPHOUS)
Ingred Name:ASBESTOS
Fraction by Wt: 6%
Other REC Limits:NONE
OSHA PEL:2FIB/CC
ACGIH TLV:2FIB/CC
Ingred Name:CELLULOSE (PAPER FIBER)
CAS:9004-34-6
RTECS #:FJ5691460
Fraction by Wt: 35%
Other REC Limits:NONE
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3; 9192
Ingred Name:MISCELLANEOUS OXIDES
Fraction by Wt: 6%
Other REC Limits:15MG/M*3
Ingred Name:IRON (CORE WIRE INGREDIENT)
CAS:7439-89-6
RTECS #:NO4565500
Fraction by Wt: 99.5%
Other REC Limits:NONE
OSHA PEL:10MG/M*3(DUST,FUME)
ACGIH TLV:5MG/M*3(DUST,FUME)
Ingred Name:MANGANESE (SARA III)
CAS:7439-96-5
RTECS #:OO9275000
Fraction by Wt: 0.5%
Other REC Limits:NONE
OSHA PEL:(C) 5 MG/M3 DUST
ACGIH TLV:5 MG/M3 DUST 9293
===================== Hazards Identification =====================
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Explanation of Carcinogenicity:ASBESTOS IS A HUMAN CARCINOGEN.
Effects of Overexposure:FUMES INHALATION:FAINTNESS,POSSIBLE NAUSEA
======================= First Aid Measures =======================
First Aid:INHALATION:REMOVE TO FRESH AIR,CALL A PHYSICIAN.
======================Handling and Storage ======================
Other Precautions:ARC & SPARKS COULD BE SOURCE OF IGNITION OF
COMBUSTIBLE PRODUCTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESP DEVICE IN ACCORD WITH
EXPOSURE OF CONCERN
Ventilation:LOCAL/MECHANICAL
Other Protective Equipment:PROTECTIVE CLOTHING,LEATHER APRON
Supplemental Safety and Health
ADD INGRED:MISCELLANEOUS OXIDES 6% TLV: 15 MG/CUM(MFR). CORE WIRE
INGRED INCLUDE IRON 99.5% TLV:5 MG/CUM;MANGANESE 0.5% TLV: C,5
MG/CUM DUST OR 1 MG/CUM FUMES.
================== Physical/Chemical Properties ==================
HCC:N1
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:SUR PREP II, 93-600
CAGE:33200
CAGE:33200
============= Composition/Information on Ingredients =============
Ingred Name:METHANE, DICHLORO-; (METHYLENE CHLORIDE)
CAS:75-09-2
RTECS #:PA8050000
Fraction by Wt: 30%
Other REC Limits:75 PPM (MFR)
OSHA PEL:500 PPM;1000 PPM, C
ACGIH TLV:50 PPM, C
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:FORMIC ACID
CAS:64-18-6
RTECS #:LQ4900000
Fraction by Wt: 15%
Other REC Limits:100 PPM (MFR)
OSHA PEL:5 PPM
ACGIH TLV:5 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ACETIC ACID
CAS:64-19-7
RTECS #:AF1225000
Fraction by Wt: 35%
Other REC Limits:10 PPM (MFR)
OSHA PEL:10 PPM
ACGIH TLV:10 PPM;15 PPM STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 20%
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SUPP DATA: PARTLY ENCLOSED OR LOW LYING AREAS, SUCH AS
TANKS OR SUMPS.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC: DISTANCE. NO SMOKING IN AREA OF USE. DO NOT USE
IN GENERAL VICINITY OF ARC WELDING, OPEN FLAMES, (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6: HOT SURF. HEAT & OR UV RADIATION MAY CAUSE FORMATION
OF HCL & OR PHOSGENE .
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHAL: DIZZ, HDCH, INTOXICATION,
SEVERE NOSE & THROAT IRRIT. SKIN: SEVERE BURNS, DEFAT. EYES: SEVERE
DMG, MAY CAUSE BLINDNESS. SEVERE CHEST PAIN IN VICINITY OF BREAST
BONE MAY INDICATE ACCUM OF DANGER OUS LEVS OF CARBOXY HEMOGLOBIN BY
METABOLISM OF METHYLENE CHLORIDE TO CO. GET MD. CHLOROCARBON (EFTS
OF OVEREXPOS)
Explanation of Carcinogenicity:METHYLENE CHLORIDE: IARC GROUP 2B, NTP
GROUP 2.
Effects of Overexposure:HLTH HAZ: MATLS HAVE PRODUCED SENSITIZATION OF
THE MYOCARDIUM TO EPINEPHRINE IN LABORATORY ANIMALS AND COULD HAVE
A SIMILAR EFFECT IN HUMANS. ADRENOMIMETICS (I.E. EPINEPHRINE) MAY
BE CONTRA-INDICATED EXCEPT FOR LIFE-SUSTAINING USES IN HUMANS
ACUTELY OR CHRONICALLY EXPOSED TO CHLOROCARBONS OR CFCS .
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:IF SEV CHEST PAIN, GET MD. INHAL:REMOVE TO FRESH AIR. IF
BRTHG DFCLT, ADMINISTER OXYGEN. IF BRTHG HAS STOPPED APPLY ARTF
RESP. GET MD. EYES:FLUSH W/LRG VOLUMES OF WATER FOR AT LEAST 15
MIN. GET MD IMM ED. SKIN:REMOVE CONTAM CLTHG. LAUNDER BEFORE REUSE.
WASH AFFECTED SKIN AREA W/SOAP & WATER. IF IRRIT
PERSISTS/BLISTERING OF SKIN OCCURS, GET MD. INGEST:DO NOT INDUCE
VOMIT. DILUTE BY (SUPP DATA)
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:NONE TO BOIL PT
Lower Limits:6.5%
Extinguishing Media:CO*2, FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED PRESSURE DEMAND SCBA
& FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:THERM DECOMP MAY PROD TOX
CO*X&CHLORINE.DRUMS EXPSD TO EVEN MOD HEAT MAY DEV SUFF INTERNAL
PRESS TO RUPT.OTHER THERM DECOMP PRODS MAY INCL HCL & PHOSGENE
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN SPILLAGE. VENTILATE AREA. WIPE UP OR
ABSORB SPILLAGE ONTO ABSORBENT MATERIAL. RECOVER IN DRUMS FOR
DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE CARE IN OPENING DRUMS TO AVOID
SPURTING OF CONTENTS.
Other Precautions:VAPS FROM PROD ARE HVR/AIR & WILL TRAVEL ALONG GROUND
TO COLLECT IN LOW LYING AREAS. PERS ENTERING SUCH AREAS MUST BE
PROVIDED W/RESP PROT & SAFETY LINE. THEY SHOULD BE KEPT UNDER
OBSERVATION WHILE IN AREA BY ANOTHER MAN AT SAFE (ING 6)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF TLV IS EXCEEDED A NIOSH/MSHA APPRVD SCBA,
POSITIVE PRESS HOSE MASK/AIR-LINE MASK IS ADVISED. THESE SHOULD
HAVE A NIOSH/MSHA APPRVD FULL FACEPIECE & BE OPER IN PRESS
DMD/OTHER POSITIVE PRESS MODE. F OR EXPOS OF NO MORE THAN 30 (SUPP
DATA)
Ventilation:LOCAL EXHAUST RECOMMENDED.
Other Protective Equipment:SOLVENT RESISTANT BOOTS AND APRON
(NEOPRENE). EMERGENCY EYEWASH & DELUGE SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRST AID PROC:GIVING LRG VOLUMES OF MILK/WATER. GET MD IMMED.
TRANSPORT TO HOSPITAL AS SOON AS POSSIBLE. RESP PROT:MIN IN AREAS
OF GOOD VENT, A NIOSH/MSHA APPRVD FULL FACE MASK W/AN ORG VAP
CANISTER MAY BE USED. THESE SHOULD BE CHECKED OFTEN & THE CANISTER
REPLACED REGULARLY. THESE MUST NOT BE USED IN (ING 5)
================== Physical/Chemical Properties ==================
HCC:T6
Boiling Pt:B.P. Text:105F,41C
Vapor Pres:380
Vapor Density:1+
Spec Gravity:1.25
Evaporation Rate & Reference:1+ (N-BUTYL ACETATE = 1)
Solubility in Water:MODERATE
Appearance and Odor:DARK BROWN VISCOUS LIQUID; SHARP VINEGAR-LIKE ODOR.
Percent Volatiles by Volume:95
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:TOXIC CO*X AND CHLORINE (CO, PHOSGENE,
ETC.) HCL, PHOSGENE .
==================== Disposal Considerations ====================
Waste Disposal Methods:LANDFILL UNDER APPLICABLE FEDERAL, STATE AND
LOCAL REGULATIONS. BURN IN A CHEMICAL FURNACE WITH APPROPRIATE FUME
SCRUBBING SYSTEM. TRANSFER TO RECLAIMING CENTER FOR SOLVENT
RECOVERY.
| 1 |
gloves_mandatory
|
===================== Product Identification =====================
Product ID:ISOPARAFFINIC PETROLEUM SOLVENT
CAGE:72190
CAGE:4N760
CAGE:72190
============= Composition/Information on Ingredients =============
Ingred Name:HYDROTREATED MIDDLE PETROLEUM DISTILLATE
CAS:64742-46-7
RTECS #:JN9379645
Fraction by Wt: NP
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE:SLIGHTLY IRRIT BUT DOESNT INJURE
EYE TISSUE.SKIN:LOW ORDER OF TOXICITY.FREQU/PROL CONTACT MAY IRRIT
& CAUSE DERM.INHAL:HIGH VAP/AEROSOL CONC(>APPROX 700PPM ATTAINABLE
@ELEVATED TEMP)IRRIT EYE/RESP TRACT,MAY CAUSE
HEAD,DIZZ,ANESTHESIA,DROWS,UNCONSC,OTHER CNS EFFECTS INCLUDING
DEATH.INGEST:MIN TOXICITY.SM AMTS(SUPPL)
Effects of Overexposure:SLIGHT EYE IRRIT, IRIT SKIN, DERM, IRRIT
EYE/RESP TRACT, HEADACHE, DIZZINESS, ANESTHESIA, DROWSINESS,
UNCONSC, OTHER CNS EFFECTS, DEATH.SMALL AMTS ASPIRATED INTO
RESPIRATORY SYSTEM MAY CAUSE MILD TO S EVERE PULMONARY INJURY
POSSIBLY PROGRESSING TO DEATH.
Medical Cond Aggravated by Exposure:SKIN CONTACT MAY AGGRAVATE EXISTING
DERM CONDITION.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH W/LG AMTS OF WATER TIL IRRIT SUBSIDES.IRRIT PERSIST
GET MED ATTN.SKIN:FLUSH W/LG AMTS OF WATER;USE SOAP IF AVAIL.REMOVE
GROSSLY CONTAM CLOTH INCLUDE SHOES.INHAL:USING PROPER RESP
PROTECTIONIMMED REMOVE AFFECTED VICTIM FRM EXPO.ADMINISTER ART
RESP IF BREATH STOP.KEEP @REST.CALL FOR PROMPT MED ATTN.INGEST:DONT
INDUCE VOMIT.KEEP @REST.GET PROMPT MED.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:239F,115C
Autoignition Temp:Autoignition Temp Text:594F
Lower Limits:0.6
Upper Limits:7.0
Extinguishing Media:USE FOAM,DRY CHEMICAL,OR WATER SPRAY TO EXTINGUISH
FIRE.
Fire Fighting Procedures:USE WATER SPRAY TO COOL FIRE EXPO SURF/PROTECT
PERSONNEL.ISOLATE "FUEL"SUPPLY FRM FIRE.AVOID SPRAYING WATER
DIRECTLY INTO STORAGE CNTNT DUE TO DANGER OF BOILOVE
Unusual Fire/Explosion Hazard:LIQ CAN BURN UPON HEATING TO TEP
@/>FLASHPT.MATL CAN ACCUMULATE STATIC CHARGES WHICH CAN CAUSE
INCENDIARY ELECT DISCHARGE.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE IGN SOURCES.PREVENT ADDN MATL DISCHARGE
W/O HAZ.SM_IMPLEMENT CLEANUP PROCEDURES.LG-IMPLEMENT CLEANUP
PROCEDURES.KEEP PUBLIC AWAY,ADVISE AUTHORITIES.IF PROD SUBJ TO
CERCLA REPORTING NOTIFY NAT R ESP CNTNR.PREVENT SEWRE/H2OCOUSE/LOW
AREA(NEUTRA)
Neutralizing Agent:SPILL:ENTRY-CONTAIN
W/SAND/EARTH.RECOVER-PUMP/ABSORBENT.H2O-SKIM/ADSORBENT.
======================Handling and Storage ======================
Handling and Storage Precautions:HEALTH STUDIES HAVE SHOWN THAT MANY
PETRO HYDROCARBONS POSE POT HUMAN HEALTH RISK-MAY VARY FRM PERSON
TO PERSON.PRECAUT-MIN LIQ/VAP MIST/FUME EXPO.
Other Precautions:DONT MIX/STORE W/STRONG OXIDANTS(LIQ CHLORINE,CONC
OXY).EMPTY CNTNR RETAIN PROD RESIDUE(LIQ &/OR VAP)-CAN BE
DANGEROUS.DONT PRESSURIZE,CUT,WELD,BRAZE,SOLDER,DRILL,GRIND,EXPO
SUCH CNTNR TO HEAT/FLAME/S PARK/STAT ELECT/IGN SOURCES-MAY (SUPPLE)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHERE CONC IN AIR MAY EXCEED LIMITS GIVEN &
ENGINEERING,WORK PRACTICE OR OTHER MEANS OF EXPOSURE REDUCTION ARE
NOT ADEQUATE NIOSH/MSHA APPROVED RESPIRATORS MAY BE NECESSARY TO
PREVENT OVEREXPO BY INHA L.
Ventilation:USE OF MECHANICAL DILUTION VENTI RECOMMENDED WHENEVER
PRODUCT IS USED IN CONFINED SPACE,HEATED >AMB TEMP, OR AGITATED.
Other Protective Equipment:LONG SLEEVES
Work Hygienic Practices:LAUNDER CONTAM CLOTH BEF REUSE.STORAGE
TEMP/PRESSURE/TEMP/VISCO:AMBT/ATM/AMBT/NOT AVAIL.
Supplemental Safety and Health
HEALTH:ASPIRATED INTO RESP SYS DURING INGEST/VOMIT MAY CAUSE MILD TO
SEVERE PULM INJURY,POSSIBLY PROGRESSING TO DEATH.CHRONIC TOXICITY
DATA AVAI UPON REQUEST. OTHER PRECAUT:EXPLO,CAUSE INJURY/DEATH.EM
PTY DRM SHOULD BE COMPLETELY DRAIN PROPERLY BUNG PROMPTLY RETURNED
TO DR RECONDITIONER/PROPERLY DISPO OF.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:532F,278C
Melt/Freeze Pt:M.P/F.P Text:<32F,<0C
Decomp Temp:Decomp Text:NP
Vapor Pres:<0 @100F
Vapor Density:<6.00
Spec Gravity:0.82
pH:NP
Viscosity:9CST @77F
Evaporation Rate & Reference:<0.0, BUTYLE ACETATE=1
Solubility in Water:<0.10 @68F, NEGLIGIB
Appearance and Odor:CLEAR COLORLESS LIQUID
Percent Volatiles by Volume:NP
Corrosion Rate:NP
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDANTS SUCH AS LIQ CHLORINE,CONC OXY,SODIUM OR CALCIUM
HYPOCHLORITE.
Hazardous Decomposition Products:NO UNUSUAL. NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:CONSULT EXPERT ON DISPO OF RECOVERED MATL,ENSURE
CONFORMITY OT LOC DISPO REGS.ACCIDENTALLY SPILL NOT SUBJ TO ANY
SPECIAL REPORTING UNDER CERCLA.CONTACT LOC AUTHORITIES TO DETERMINE
IF THERE MAY BE OTH ER LOC REPORTING REQMTS.
| 1 |
gloves_mandatory
|
Subsets and Splits
No community queries yet
The top public SQL queries from the community will appear here once available.