text
stringlengths 542
18.7k
| label
int64 0
1
| label_text
stringclasses 2
values |
|---|---|---|
===================== Product Identification =====================
Product ID:MIL-H-83282C HY FLUID,
Preparer's Name:RICHARD J. EBERHARDT
CAGE:8Y842
CAGE:8Y842
CAGE:0PGK2
============= Composition/Information on Ingredients =============
Ingred Name:POLYALPHAOLEFIN BASE STOCK
CAS:68649-12-7
Fraction by Wt: <65%
Other REC Limits:NONE RECOMMENDED
Ingred Name:ADIPIC ACID, DIISODECYL ESTER
CAS:27178-16-1
RTECS #:AV1485000
Fraction by Wt: <35%
Other REC Limits:NONE RECOMMENDED
Ingred Name:LUBRICANT ESTER BASE
CAS:110-29-2
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:PRODUCT'S LD50 (ORAL RAT) WAS NOT STATED
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NOT NORMALLY EXPECTED TO CAUSE ANY ILL
EFFECTS EXCEPT IN VERY SENSITIVE INDIVIDUALS. CHRONIC-I/A/W
FEDERAL, STATE & LOCAL REGULATIONS MAY CAUSE MILD IRRITATION &
INFLAMATION.
Explanation of Carcinogenicity:MANUFACTURER GAVE NO INFORMATION ABOUT
CARCINOGENICITY. HMIS FOUND NO LISTING & DOES NOT EXPECT IT TO BE
CARCINOGENIC.
Effects of Overexposure:MILD IRRITATION & INFLAMATION.
Medical Cond Aggravated by Exposure:PERSONNEL W/PRE-EXISTING SKIN
DISORDERS SHOULD AVOID CONTACT.
.
======================= First Aid Measures =======================
First Aid:IF IRRITATION PERSISTS OR IS SEVERE, GET MEDICAL ATTENTION.
EYE:FLUSH W/WATER FOR 15 MIN. SKIN:WASH W/SOAP & WATER. REMOVE
CONTAMINATED CLOTHING & LAUNDER BEFORE REUSE. INHALED:REMOVE FROM
EXPOSURE. A ID OR RESTORE BREATHING AS NEEDED. INGESTED:DO NOT
INDUCE VOMITING. GET IMMEDIATE MEDICAL ATTENTION.
.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:>392F,>200C
Lower Limits:N/A.
Upper Limits:N/A.
Extinguishing Media:WATER FOG, FOAM, DRY CHEMICAL/CARBON DIOXIDE.
Fire Fighting Procedures:DO NOT ENTER ANY ENCLOSED OR CONFINED AREA
WITHOUT PROPER PROTECTIVE EQUIPMENT & SELF-CONTAINED BREATHING
APPARATUS.
Unusual Fire/Explosion Hazard:SLIGHTLY COMBUSTIBLE. WHEN HEATED ABOVE
FLASH POINT, WILL RELEASE FLAMMABLE VAPORS WHICH CAN BURN IN OPEN
OR BE EXPLOSIVE IN CONFIED SPACES.
================== Accidental Release Measures ==================
Spill Release Procedures:STOP FLOW, WIPE UP OR ABSORB W/DIOMACEOUS
EARTH OR OTHER INERT MATERIAL. STORE IN APPROPRIATE CONTAINER FOR
DISPOSAL.
Neutralizing Agent:MFR GAVE NO INFORMATION OF MSDS.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID STORAGE NEAR OPEN FLAME OR OTHER
SOURCES OF IGNITION. EXCESSIVE MISTING MAY CAUSE SLIPPERY FLOORS.
PORPER FOOTWEAR REQUIRED.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED.
Ventilation:SUFFICIENT TO MAINTAIN ATMOSPHERE BELOW TLV LIMIT.
Other Protective Equipment:MFR GAVE NO INFORMATION OF MSDS.
Work Hygienic Practices:WASH HANDS W/SOAP & WATER BEFORE EATING,
DRINKING OR SMOKING.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:V6
NRC/State Lic Num:NONE
Boiling Pt:B.P. Text:>599F,>315C
Vapor Pres:<0.01
Vapor Density:>1
Spec Gravity:0.853
Solubility in Water:NEGLIGIBLE
Appearance and Odor:RED, OILY LIQUID - PETROLEUM ODOR
Percent Volatiles by Volume:NIL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:DO NOT HEAT ABOVE FLASH POINT
Hazardous Decomposition Products:CARBON MONOXIDE AND ASPHYXIANTS
==================== Disposal Considerations ====================
Waste Disposal Methods:I/A/W FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ENAMEL INTERIOR SG GREEN 24233 ID752426
Preparer's Name:W.A. ELLISON
CAGE:FO127
CAGE:FO127
CAGE:61196
============= Composition/Information on Ingredients =============
Ingred Name:MINERAL SPIRITS
(VAPOR PRESSURE 2 MM HG @ 20 DEC C.)
CAS:64742-88-7
Fraction by Wt: 10%
OSHA PEL:500 PPM 2950 MG/CU M
ACGIH TLV:100 PPM 525 MG/CU M
Ingred Name:NEPTANE
(VAPOR PRESSURE 40 MM)
Fraction by Wt: 20%
ACGIH TLV:400 PPM
Ingred Name:VOC. ORGANIC CMPD 3.26 LB/GL LESS WATER & NPRS* 391 G/L
LESSWATER 5.91 LB/GAL SOLIDS 709 G/L SOLIDS CALCULATED.
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SWALLOWING;GASTROINTESTINAL
IRR/NAUSEA/VOMIT/DIARRHEA.ASPIRATION OF MAT'L INTOLUNGS-CHEM
PNEUMONITIS-FATAL.INHALATION:ANESTHETIC.IRR OF NOSE/THROAT/ACUTE
NERVOUS SYS DEPRESSION. CHAR BY HEADACHE , DIZZINESS.
CONFUSION/NAUSEA/UNCONSCIOUSNESS/ASPHYXIATION. EYE: IRRITATION
SKIN: DEFATTING AND IRRITATION.
Effects of Overexposure:PROLONGED AND REPEATED OCCUPATIONAL
OVEREXPOSURE TO SOLVENTS W/PERMANENT BRAIN AND NERVOUS SYSTEM
DAMAGE. INTENTIONAL MISUSE BY DELIVERATELY CONCENTRATING AND
INHALING THE CONTENTS MAY BE HARMFUL OR F ATAL.
======================= First Aid Measures =======================
First Aid:SWALLOWING: DONOT INDUCE VOMITING CALL POISON CONTROL CENTER,
EMERG ROOM. INHALATION: REMOVE TO FRESH AIR IF BREATHING STOPPED
GIVE CPR. EYE: FLUSH W/LG AMTS OFWATER LIFTING LIDS FOR 15 MINUTES.
GET M EDICAL ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING. WASH
AFFECTED AREA W/SOAP AND WTR. SEEK MEDICAL ATTENTION IF IRRITATION
PERSISTS. PHYSICAN TREATMENT SHOULD BE DIRECTED AT CONTROL OF
SYMPTOM.
===================== Fire Fighting Measures =====================
Flash Point:102F/38.89C
Extinguishing Media:CLASS B FIRE EXTINGUISHERS DESIGNED TO EXTINGUISH
FLAMMABLE LIQUID FIRES. POLYMER FOAM IS PREFERRED FOR LARGE FIRES.
Fire Fighting Procedures:WEAR SELF CONTAINED BREATHING APPARATUS. WATER
MAY BE INNEFECTIVE, BUT MAY BE USED TO PREVENT PRESSURE BUILD-UP.
IF WATER IS USED, FOG NOZZLES ARE PREFERABLE.
Unusual Fire/Explosion Hazard:DURING EMERG CONDITIONS, OVEREXPOSURE TO
DECOMP PRODUCTS MAY CAUSE A HEALTH HAZ.GET MED ATTN.KEEP CONTNR
TIGHTLY CLOSD. MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT
================== Accidental Release Measures ==================
Spill Release Procedures:KEEP SPECTATORS AWAY. ELIMINATE IGNITION
SOURCES. DIKE AND CONTAIN SPILL W/INERT MATERIAL. TRANSFER LIQUIDS
TO COVERED METAL CONTAINERS FOR RECOVERY. PREVENT CONTAMINATION OF
SEWERS, STREAMS, AND GROU ND MATERAL W/SPILLED MATERIAL.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 95F. STORE LARGE
QUANTITIES IN COMPLIANCE WITH OSHA 29CFR1910.106. DO
NOT TAKE INTERNALLY. CLOSE CONTAINER AFTER USE.
Other Precautions:EMPTY CONTAINERS MUST NOT BE WASHED AND RE-USED FOR
ANY PURPOSE. CONTAINERS SHOULD BE GROUNDED AND BONDED TO THE
RECEIVING CONTAINER. DO NOT WELD, BRAZE OR CUT ON EMPTY CONTAINERS.
NEVER USE PRESSURETO EMPTY. DRUM IS NOT A PRESSURE VESSEL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQD IN WELL VENTILATED AREAS. RESTRICTED
AREAS A NIOSH APPROVED CHEMICAL CARTRIDGE RESPIRATOR MAYBE REQD.
UNDER CERTAIN COND (SPRAYING) MECHANICAL PREFILTER MAY BE REQD.
Ventilation:PROVIDE GENERAL DILUTION AND LOCAL EXHAUST VENTILATION IN
SUFFICIENT VOLUME AND PATTERN TO MAINTAIN CONCENTRATIONS.
Other Protective Equipment:NOT LIKELY NEEDED
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:281-388F
Vapor Density:>THAN AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:44
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS OR ALKALINE MATERIALS
Stability Condition to Avoid:AVOID EXCESSIVE HEAT AND SOURCES OF
IGNITION.
Hazardous Decomposition Products:BURNING,INCLUDING WHEN HEATED BY
WELDING OR CUTTING, WILL PRODUCE SMOKE, CARBON MONOXIDE AND CARBON
DIOXIDE.
Conditions to Avoid Polymerization:KEEP AWAY FROM HEAT SPARKS AND
FLAME.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IAW FEDERAL, STATE AND LOCAL LAWS.
OBSERVEPRECAUTIONS FOR DISPOSAL OF FLAMMABLE MATERIAL. DO NOT
INCINERATE IN CLOSED CONTAINERS. PROPER RCRA
CLASSIFICATION WOULD BE D001.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MIX 39C
CAGE:EO710
CAGE:19740
CAGE:EO710
============= Composition/Information on Ingredients =============
Ingred Name:PARTICULATES NOT OTHERWISE REGULATED (NUISANCE DUST)
Fraction by Wt: 100%
OSHA PEL:15 MG/M3 TOTAL DUST
ACGIH TLV:10 MG/M3 TDUST; 8990
===================== Hazards Identification =====================
Effects of Overexposure:NUISANCE DUST MAY CAUSE NASAL/THROAT/LUNG
IRRITATION/DISCOMFORT: MAY AGGRAVATE BRONCHIAL DISORDERS
======================= First Aid Measures =======================
First Aid:TERMINATE EXPOSURE.
======================Handling and Storage ======================
Handling and Storage Precautions:THIS PRODUCT AS MANUFACTURED IS AN
ALUMINOSILICATE WHICH COULD TRANSFORM UPON HEATING TO
MULLI/CRISTOBALITE (A FORM OF CRYSTALLINE SILICA).
Other Precautions:REMOVAL OF THIS PRODUCT AFTER USE MAY RESULT IN THE
GENERATION OF DUST. REPEATED INHALATION OF RESPIRABLE FREE
CRYSTALLINE SICA DUST MAY CAUSE DELAYED LUNG INJURY (SILICOSIS)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED OR FULL FACEPIECE RESPIRATOR
W/APPROPRIATE FILTER PAD
Ventilation:LOCAL EXHAUST AND MECHANICAL
Other Protective Equipment:AS REQUIRED TO MEET APPLICABLE OSHA
STANDARDS.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Spec Gravity:3.1
Solubility in Water:INSOLUBLE
Appearance and Odor:COARSE AGGREGATE WITH FINE POWDERED MATRIX
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:ROUTINE HOUSEKEEPING.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:P-7530, INSTITUTIONAL BAB-O CLEANSER W/ (SU
CAGE:PUREX
CAGE:PUREX
CAGE:0BYN5
============= Composition/Information on Ingredients =============
Ingred Name:BENZENESULFONIC ACID, DODECYL-, SODIUM SALT; (SODIUM LINEAR
ALKYL BENZENE SULFONATE) (SARA III)
CAS:25155-30-0
RTECS #:DB6825000
Fraction by Wt: <10%
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SILICON DIOXIDE, AMORPHOUS
CAS:7631-86-9
Fraction by Wt: >80%
Other REC Limits:0.1 MG/M3 (MFR)
OSHA PEL:6 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN:SLIGHT IRRITANT. INHAL:NO
EFFECTS OF EXPOSURE EXPECTED. INGEST:SLIGHTLY TOXIC.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NO DATA FOUND.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE
O2/ARTIFICIAL RESPIRATION) . EYES:FLUSH WITH LARGE AMOUNTS OF WATER
FOR AT LEAST 15 MINUTES. SKIN:FLUSH WITH WATER. INGEST:GIVE SEVERAL
GLASSES OF WATER OR MILK TO DILUTE INGESTED PRODUCT.
===================== Fire Fighting Measures =====================
Extinguishing Media:NONE REQUIRED. MEDIA SUITABLE FOR SURROUNDING FIRE
.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . IF WETTED WITH WATER, CHLORINE IS FORMED.
Unusual Fire/Explosion Hazard:IF WETTED WITH WATER, CHLORINE IS FORMED.
================== Accidental Release Measures ==================
Spill Release Procedures:CONCENTRATE:SWEEP UP BUT DO NOT USE SWEEPING
COMPOUNDS. PLACE IN SUITABLE CONTAINERS. SOLUTION:FLUSH WITH WATER
INTO WASTE TREATMENT SYSTEMS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NORMAL HANDLING METHODS; INSIDE
STORAGE AT 30-120F RECOMMENDED. KEEP DRY.
Other Precautions:A PROGRAM OF REGULAR CLEANING, REPAIRING AND
REPLACING OF WORN-OUT PARTS AND CONTAMINATED EQUIPMENT IS HIGHLY
DESIRABLE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED. WEAR NIOSH/MSHA APPROVED
RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:NORMAL VENTILATION MEANS.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:USE ADEQ WASHING FACILITIES. WASH HANDS/OTHER
CONT AREAS THORO. CHANGE CLTHG IF WETTED W/PROD. DO NOT REUSE
(SUPDAT)
Supplemental Safety and Health
MFR'S TRADE NAME/PART NO: CHLORINE BLEACH. HYGIENE PRACT:CLOTHING
WETTED WITH PRODUCT BEFORE CLOTHING IS LAUNDERED.
================== Physical/Chemical Properties ==================
HCC:N1
Solubility in Water:10%
Appearance and Odor:WHITE POWDER WITH SLIGHT FLORAL ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:DO NOT MIX LIQUID ACIDS OR REDUCING
AGENTS.
Hazardous Decomposition Products:CHLORIMINES.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONCENTRATE:BURY IN SUITABLE LANDFILL IN
ACCORDANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS. SPENT
SOLUTION AND RINSES:FLUSH WITH WATER INTO WASTE TREATMENT SYSTEMS
IN ACCORDANCE WITH LOCAL, STATE A ND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TOUGH COAT ALKYD ENAMEL, 727-1704 GLOSS RED
CAGE:MART2
CAGE:MART2
CAGE:54636
============= Composition/Information on Ingredients =============
Ingred Name:KEROSENE (PETROLEUM), HYDROTREATED; (MINERAL SPIRITS). VP:
2.0
CAS:64742-47-8
RTECS #:OA5504000
Fraction by Wt: 46%
OSHA PEL:100 STEL (MFR)
ACGIH TLV:100 STEL (MFR)
Ingred Name:SOLVENT NAPHTHA, PETROLEUM, MEDIUM ALIPHATIC; (MINERAL
SPIRITS, 140-FLASH). VP: 2.0
CAS:64742-88-7
RTECS #:WF3450000
Fraction by Wt: 46%
OSHA PEL:100 STEL (MFR)
ACGIH TLV:100 STEL (MFR)
Ingred Name:XYLENE (SARA 313) (CERCLA). VP: 7.1
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 1%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/150STEL;9495
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:VOLATILE ORGANIC COMPOUNDS (VOC) - 3.85 LBS/GAL
RTECS #:9999999VO
Ingred Name:WASTE DISP METH:LOCAL REGULATIONS REGARDING POLLUTION.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC:THE APPLICABLE LIMITS FOR NUISANCE DUSTS ARE
ACGIH TLV 10 MG/M3 (TOTAL DUST), OSHA PEL 15 MG/M3 (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6:(TOTAL DUST), 3 MG/M3 (RESPIRABLE FRACTION). KEEP
AWAY FROM HEAT, SPARKS, & OPEN FLAME. VAPS WILL (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7:ACCUM READILY & MAY IGNITE EXPLOSIVELY. DURING USE &
UNTIL ALL VAPS ARE GONE:KEEP AREA VENT-DO NOT (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8:SMOKE-EXTINGUISH ALL FLAMES, PILOT LIGHTS, &
HEATERS-TURN OFF STOVES, ELECTRIC TOOLS & APPLICANCES, & (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9:ANY OTHER SOURCES OF IGNIT. CONSULT NFPA CODES. USE
APPRVD BONDING & GROUNDING PROC. KEEP CNTNR CLOSED (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10:WHEN NOT IN USE. TRANSFER ONLY TO APPRVD CNTNRS
W/COMPLETE & APPROP LABELING. DO NOT TAKE INTERNALLY. (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11:KEEP OUT OF THE REACH OF CHILDREN. INTENTIONAL
MISUSE BY DELIBERATELY CONCENTRATING & INHALING THE (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12:CONTENTS CAN BE HARMFUL OR FATAL.
RTECS #:9999999ZZ
Ingred Name:RESP PROT:RESP (TOTAL DUST), 5 MG/M3 (RESPIRABLE FRACTION).
RTECS #:9999999ZZ
Ingred Name:VENT:LIMITS. REFER TO OSHA STANDARDS 1910.94, 1910.107,
1910.108.
RTECS #:9999999ZZ
Ingred Name:EFTS OF OVEREXP:EVIDENCE TO INDICATE IT CAUSES BIRTH
DEFECTS IN HUMANS. RATS EXPOSED TO TITANIUM DIOXIDE DUST (ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16:AT 250 MG/M3 DEVELOPED LUNG CANCER, HOWEVER, SUCH
EXPOSURE LEVELS ARE NOT ATTAINABLE IN THE WORKPLACE. (ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17:REPORTS HAVE ASSOCIATED REPEATED & PROLONGED
OVEREXPOSURE TO SOLVENTS W/PERMANENT BRAIN & NERVOUS SYSTEM DAMAGE.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: IRRIT OF EYES, SKIN & RESP SYS.
MAY CAUSE NERVOUS SYS DEPRESS. EXTREME OVEREXP MAY RSLT IN
UNCONSCIOUSNESS & POSS DEATH. SIGNS & SYMPS OF OVEREXP: HDCH, DIZZ,
NAUS, & LOSS OF COORDINATION ARE I NDICATION OF EXCESSIVE EXPOS TO
VAPS/SPRAY MISTS. REDNESS & ITCHING/BURNING SENSATION MAY INDICATE
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:EYE/EXCESSIVE SKIN EXPOS.
CHRONIC:PRLNGD OVEREXP TO SOLV INGS IN ING SECTION MAY CAUSE
ADVERSE EFTS TO THE LIVER & URINARY SYS. ETHYLENE GLYCOL IS
CONSIDERED AN ANIMAL TERATOGEN. IT HAS BEEN SHOWN TO CAUSE BIRTH
DEFECTS IN RATS & MICE AT HIGH DOSES WHEN GIVEN IN DRINKING
WATER/BY GAVAGE. THERE IS NO (ING 16)
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.
======================= First Aid Measures =======================
First Aid:INHAL: IF AFFECTED, REMOVE FROM EXPOSURE. RESTORE BREATHING.
KEEP WARM AND QUIET. SKIN: WASH AFFECTED AREA THOROUGHLY WITH SOAP
AND WATER. REMOVE CONTAMINATED CLOTHING AND LAUNDER BEFORE RE-USE.
EYES: FLUSH EYES WITH LARGE AMOUNTS OF WATERFOR AT LEAST 15
MINUTES. GET MEDICAL ATTENTION. INGEST: GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:>99F,>37C
Lower Limits:1.0%
Upper Limits:6.0%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:USE NIOSH APPRVD SCBA & FULL PROT EQUIP .
WATER SPRAY MAY BE INEFT. IF H*2O IS USED, FOG NOZZLES ARE PREF.
H*2O MAY BE USED TO COOL CLSD CNTNRS (SUPDAT)
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM
HEAT, ELEC EQUIP, SPARKS, & OPEN FLAME. CLSD CNTNRS MAY EXPLODE
WHEN EXPOSED TO EXTREME HEAT. APPLICATION TO (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE ONLY WITH ADEQUATE VENTILATION.
AVOID BREATHING VAPOR AND SPRAY MIST. AVOID CONTACT WITH SKIN AND
EYES.
Other Precautions:THESE COATINGS MAY CNTN MATLS CLASSIFIED AS NUISANCE
PARTICULATES (LISTED 'AS DUST' IN ING SECTION) WHICH MAY BE PRESENT
AT HAZ LEVELS ONLY DURING SANDING/ABRADING OF THE DRIED FILM. IF NO
SPECIFIC DU STS ARE LISTED IN ING SECTION, (ING 6)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF PERS EXPOS CANNOT BE CONTROLLED BELOW APPLIC
LIMS BY VENT, WEAR A PROPERLY FITTED ORG VAP/PARTICULATE RESP
APPRVD BY NIOSH FOR PROT AGAINST MATLS IN ING SECTION. WHEN
SANDING/ABRADING THE DRIED FIL M, WEAR A NIOSH APPRVD DUST/MIST(ING
14)
Ventilation:LOC EXHST PREF. GEN EXHST ACCEPTABLE IF THE EXPOS TO MATLS
IN ING SECTION IS MAINTAINED BELOW APPLICABLE EXPOS (ING 15)
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:WASH HANDS AFTER USING.
Supplemental Safety and Health
FIRE FIGHT PROC:TO PVNT PRESS BUILD-UP & POSS AUTOIGNITION/EXPLOSION
WHEN EXPOSED TO EXTREME HEAT. EXPLO HAZ:HOT SURF REQ SPECIAL PREC.
DURING EMER CNDTNS OVEREXP TO DECOMP PROD MAY CAUSE A HLTH HAZ.
SYMPS MAY NOT BE IMMED APPARENT. OBTAINMED ATTN. MATLS TO
AVOID:DANGEROUSLY INCRD PRESS IN CLSD CNTNRS.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>284F,>140C
Vapor Pres:SEE ING
Vapor Density:HVR/AIR
Spec Gravity:0.93
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
FOR CHROME ALUMINIUM ONLY-CONTAM W/H*2O, ACIDS/ALKALIS CAN CAUSE
EVOLUTION OF HYDROGEN, WHICH MAY RSLT IN (SUPDAT)
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:BY FIRE: CARBON DIOXIDE, CARBON
MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE FROM THESE PRODS MAY BE HAZS AS DEFINED
UNDER THE RCRA 40 CFR 261. WASTE MUST BE TESTED FOR IGNITABILITY TO
DETERM THE APPLIC EPA HAZS WASTE NUMBER. INCIN IN APPRVD FACILITY.
DO NOT INCIN CLSD C NTNR. DISPOSE OF I/A/W/FED, STATE & (ING 5)
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MASTER BLEND-GREY/WHITE, 6042
Preparer's Name:HAROLD WEBSTER
CAGE:CUSTO
CAGE:CUSTO
============= Composition/Information on Ingredients =============
Ingred Name:SILICA, CRYSTALLINE-QUARTZ; (SILICON DIOXIDE, CRYSTALLINE
SILICA)
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 55%
Other REC Limits:.05 MG/M3 (MFR)
OSHA PEL:10 MG/M3 (MFR)
ACGIH TLV:3 MG/M3 (MFR)
Ingred Name:SILICATE, PORTLAND CEMENT; (CALCIUM SALTS/PORTLAND CEMENT)
CAS:65997-15-1
RTECS #:VV8770000
Fraction by Wt: 40%
Other REC Limits:10 MG/M3 (MFR)
OSHA PEL:N/K
ACGIH TLV:5 MG/M3 DUST (MFR)
Ingred Name:CALCIUM CARBONATE (MARBLE) (LIMESTONE)
CAS:1317-65-3
RTECS #:EV9580000
Fraction by Wt: 5%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:WET CEMENT, ESPECIALLY AS AN
INGRED IN PLASTIC (UNHARDENED) CONCRETE, CAN DRY SKIN & CAUSE
ALKALINE BURNS. CEMENT DUST CAN IRRIT EYES & UPPER RESPIRATORY
SYSTEM. CHRONIC:CEMENT DUST CAN CAUSE IN FLAMM OF LINING TISS OF
INTERIOR OF THENOSE & INFLAMM OF EYES. HYPERSENSITIVE INDIVIDUALS
MAY DEVELOP (EFTS OF OVEREXP)
Explanation of Carcinogenicity:CRYSTALLINE SILICA (QUARTZ):IARC MONO,
SUPPLEMENT. VOL 7, PG 341, 1987:GROUP 2A. NTP 7TH ANNUAL RPT ON
CARCIN, (SUPDAT)
Effects of Overexposure:HLTH HAZ: AN ALLERGIC DERM (SKIN RASH). THIS
PROD CONTAINS 1/MORE CHEM KNOWN TO ST OF CA TO CAUSE CANCER, BIRTH
DEFECTS/OTHER REPRODUCTIVE HARM. ST OF CA (PROP. 65) REQ ABOVE
WARNING IN ABSENCE OF DEF INITIVE TESTING TO PROVE THAT DEFINED
RISKS DO NOT EXIST.
Medical Cond Aggravated by Exposure:HYPERSENSITIVE INDIVIDUALS MAY
DEVELOP SKIN RASH.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD IMMEDIATELY . EYE:IRRIGATE W/WATER FOR @ LEAST
15 MINUTES. CONSULT PHYS IMMED. SKIN:WASH EXPOSED AREAS WITH SOAP &
WATER IMMED. INHAL:WEAR APPROVED NIOSH/MSHA APPROVED RESPIRATOR IN
DUSTY ENVIRONMENT.
===================== Fire Fighting Measures =====================
Extinguishing Media:NONE KNOWN. MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN-UP USING DRY METHODS THAT DO NOT
DISPERSE DUST INTO THE AIR. AVOID BREATHING THE DUST. EMERGENCY
PROCEDURES ARE NOT REQUIRED.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:AVOID GENERATING DUST.
Other Protective Equipment:USE OF BARRIER CREAMS/IMPERVIOUS BOOTS &
CLOTHING TO PROTECT SKIN FROM CONT W/WET CEMENT.
Work Hygienic Practices:GOOD HOUSEKEEPING PROCEDURES SHOULD BE FOLLOWED
AT ALL TIMES.
Supplemental Safety and Health
EXPLAN OF CARCIN: 1994, ANTICIPATED TO BE CARCINOGEN.
================== Physical/Chemical Properties ==================
HCC:N1
Vapor Density:HVR/AIR
Spec Gravity:2.6 (H*20=1)
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:SLIGHT
Appearance and Odor:COLORED POWDER NO ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:NONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:CAN BE TREATED AS COMMON WASTE/RETURNED TO CNTNR
FOR LATER USE IF IT IS NOT CONTAMINATED. DISPOSAL MUST BE I/A/W
FEDERAL, STATE & LOCAL REGULATIONS .
| 1 | gloves_mandatory |
=======================================================
Product ID: CYANIDE INDICATOR REAGENT, 2793
Cage: IO782
Box: 329
=======================================================
Contractor Summary
=======================================================
Cage: IO782
Box: 329
Cage: 34807
Box: 329
=======================================================
Ingredients
=======================================================
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: NO
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Explanation Of Carcinogenicity: NOT RELEVANT
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: EYES:FLUSH WITH WATER FOR AT LEAST 15 MINUTES (FP N). SKIN:WASH WITH
SOAP AND WATER. CALL MD IMMEDIATELY (FP N). INGEST:GIVE PLENTY OF WATER.
CONSULT PHYSICIAN. INHAL:REMOVE TO FRESH AIR. SUPPORT BREA THING (GIVE
O*2/ARTIFICIAL RESPIRATION (FP N).
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: SWEEP UP. DISSOLVE IN WATER. WASH DOWN DRAIN WITH
EXCESS WATER.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISSOLVE IN WATER. WASH DOWN DRAIN WITH EXCESS WATER.
DISPOSE ACCORDING TO FEDERAL, STATE, AND LOCAL REGULATIONS.
Handling And Storage Precautions: NONE SPECIFIED BY MANUFACTURER.
Other Precautions: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Extinguishing Media: ALCOHOL FOAM, DRY CHEMICAL, CO*2
Fire Fighting Procedures: NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT (FP N).
=======================================================
Control Measures
=======================================================
Respiratory Protection: NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE
OF CONCERN (FP N).
Ventilation: MECHANICAL
Supplemental Safety and Health: PH:3(0.1G IN 10 ML WATER).
=======================================================
Physical/Chemical Properties
=======================================================
PH: SUPDAT
Solubility in Water: SOLUBLE
Appearance and Odor: WHITE POWDER. FISH-LIKE ODOR.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: MOISTURE
Materials To Avoid: STRONG OXIDIZERS
Hazardous Decomposition Products: CO*X, NO*X, HF
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: CYANIDE INDICATOR REAGENT, 2793
Cage: IO782
Assigned IND: Y
Company Name: LA MOTTE CO
Street: UNKNOWN
PO Box: 329
Zipcode: 21820
Label Required IND: Y
Date Of Label Review: 08/11/1994
Status Code: C
Label Date: 08/11/1994
Origination Code: G
Skin Protection IND: YES
Signal Word: NONE
Respiratory Protection IND: YES
Health Hazard: None
Contact Hazard: None
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE/CHRONIC:NONE LISTED BY MANUFACTURER.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:875 6587 VINYL WIDE FORMAT INKJET MEDIA
CAGE:19139
CAGE:19139
CAGE:5K871
============= Composition/Information on Ingredients =============
Ingred Name:PVC BASE
Fraction by Wt: 40-60%
Other REC Limits:NONE RECOMMENDED
Ingred Name:ADHESIVE BACKING
Fraction by Wt: 40-60%
Other REC Limits:NONE RECOMMENDED
Ingred Name:OTHER INGREDIENTS
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT): NOT GIVEN
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:THIS PRODUCT IS NOT EXPECTED TO CAUSE
ANY HEALTH OR SAFETY HAZARDS WHEN USED AS INTENDED. INKJET MEDIA
ARE NOT HAZARDOUS TO HEALTH.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:NONE SPECIFIED BY MANUFACTURER.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL
Fire Fighting Procedures:NONFLAMMABLE. USE STANDARD FIREFIGHTING
PROCEDURES FOR SURROUNDING MATERIALS IN THE FIRE.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:COLLECT FOR REUSE/DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:THIS PRODUCT IS NOT EXPECTED TO CAUSE
ANY HEALTH OR SAFETY HAZARDS WHEN USED AS INTENDED.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED.
Ventilation:GOOD GENERAL VENTILATION, TYPICALLY 10 AIR CHANGES PER
HOUR, SHOULD BE USED. RATES SHOULD MATCH CONDITIONS.
Other Protective Equipment:NONE SHOULD BE NEEDED.
Work Hygienic Practices:WASH HANDS THOROUGHLY WITH SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:NOT GIVEN
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Decomp Temp:Decomp Text:NOT GIVEN
Vapor Pres:NOT GIVEN
Vapor Density:NOT GIVEN
Spec Gravity:NOT GIVEN
Viscosity:NOT GIVEN
Evaporation Rate & Reference:NOT GIVEN
Solubility in Water:NOT GIVEN
Appearance and Odor:INKJET MEDIA
Percent Volatiles by Volume:NIL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:LANDFILL OR DISPOSE IN ACCORDANCE WITH LOCAL,
STATE OR FEDERAL REGULATIONS.
| 0 | gloves_not_mandatory |
=======================================================
NIIN: 00-582-5480
Product ID: 19023, MIL-PRF-17672D GR 2110 TH
Cage: 8G974
=======================================================
Item Description Information
=======================================================
Item Manager: S9G
Item Name: HYDRAULIC FLUID,PETROLEUM BASE
Specification Number: MIL-H-17672D
Type/Grade/Class: ISO GRADE 46
Unit of Issue: DR
Quantitative Expression: 00000000055GL
UI Container Qty: 1
Type of Container: DRUM
=======================================================
Ingredients
=======================================================
Cas: 64742-54-7
RTECS #: PY8035500
< Wt: 100.
Other REC Limits: NOT PROVIDED
OSHA PEL: NOT PROVIDED
ACGIH TLV: 5 MG/M3 (OIL MIST)
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NOT PROVIDED
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: PRIMARY ROUTES OF EXPOSURE: EYE: MAY CAUSE EYE IRRITATION
IF SPLASHED INTO EYES. SKIN: REPEATED OR PROLONGED CONTACT WITH SKIN MAY
CAUSE IRRITATION WHICH MAY LEAD TO VARIOUS SKIN DISORDERS. AVOID PROL ONGED
SKIN CONTACT. INHALATION: INHALATION OF VAPOR OR OIL MIST FROM THIS PRODUCT
MAY CAUSE MILD IRRITATION OF THE RESPIRATORY SYSTEM. USE IN WELL VENTILATED
AREAS. ORAL: INGESTION MAY CAUSE NAUSEA, D IARRHEA AND STOMACH DISCOMFORT.
Explanation Of Carcinogenicity: PRODUCT CONTAINS NO INGREDIENTS CURRENTLY
CLASSIFIED AS CARCINOGENIC BY NTP, IARC OR OSHA.
Signs And Symptions Of Overexposure: EYE: MAY CAUSE EYE IRRITATION IF SPLASHED
INTO EYES. SKIN: REPEATED OR PROLONGED CONTACT WITH SKIN MAY CAUSE
IRRITATION. INHALATION: INHALATION OF VAPOR OR OIL MIST FROM THIS PRODUCT MAY
CAUSE MILD IR RITATION OF THE RESPIRATORY SYSTEM. ORAL: INGESTION MAY CAUSE
NAUSEA, DIARRHEA AND STOMACH DISCOMFORT.
Medical Cond Aggravated By Exposure: PERSONNEL WITH PRE-EXISTING SKIN DISORDERS
SHOULD AVOID CONTACT.
First Aid: ORAL: DO NOT INDUCE VOMITING. IF CONSCIOUS, GIVE 2 GLASSES OF WATER.
GET IMMEDIATE MEDICAL ATTENTION. EYE: FLUSH WITH WATER AT LEAST 15 MINUTES.
GET MEDICAL ATTENTION IF EYE IRRITATION DEVELOPS OR PER SISTS. SKIN: WASH
IMMEDIATELY WITH SOAP AND WATER. REMOVE SOILED CLOTHING. GET MEDICAL
ATTENTION IF IRRITATION DEVELOPS. LAUNDER CONTAMINATED CLOTHING. INHALATION:
REMOVE EXPOSED PERSON TO FRESH AIR. IF BREATHING IS LABORED, ADMINISTER
OXYGEN AND OBTAIN IMMEDIATE MEDICAL ATTENTION. IF IRRITATION PERSISTS OR IF
TOXIC SYMPTOMS ARE OBSERVED, GET MEDICAL ATTENTION.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: EVACUATE ALL NON-ESSENTIAL PERSONNEL. PERSONAL
PROTECTIVE EQUIPMENT MUST BE WORN. REMOVE SOURCES OF IGNITION. PREVENT ENTRY
INTO SEWERS AND WATERWAYS. CONTAIN RELEASE, PICK UP FREE LIQUID FOR RECYCLIN
G OR DISPOSAL. RESIDUAL LIQUID CAN BE ABSORBED WITH INERT MATERIAL. CHECK
DOT/CERCLA AND OTHER AGENCIES FOR REPORTING REQUIREMENTS. PREVENT
CONTAMINATION TO SOIL, WATERWAY AND SEWER SYSTEMS.
Neutralizing Agent: NOT RELEVANT
Waste Disposal Methods: CONSULT FEDERAL, STATE AND LOCAL REGULATIONS REGARDING
DISPOSAL METHODS. RECYCLE USED OIL. DO NOT CONTAMINATE USED OIL WITH SOLVENTS
OR OTHER CHEMICALS. .
Handling And Storage Precautions: STORE IN CLOSED CONTAINERS OF PROPER
CONSTRUCTION. STORE AWAY FROM IGNITION SOURCES AND IN AREAS OF GOOD
VENTILATION. AVOID PROLONGED SKIN CONTACT, BREATHING VAPORS, AND CONTAMINATED
CLOTHING. USE WIT H ADEQUATE VENTILATION. WEAR RECOMMENDED PROTECTIVE
EQUIPMENT.
Other Precautions: PRACTICE GOOD PERSONAL HYGIENE AFTER HANDLING. EMPTY
CONTAINERS RETAIN MATERIAL RESIDUE. DO NOT CUT, WELD, BRAZE, SOLDER OR EXPOSE
CONTAINERS TO OTHER IGNITION SOURCES.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: COC
Flash Point: >221.1C, 430.F
Lower Limits: NOT GIVEN
Upper Limits: NOT GIVEN
Extinguishing Media: CARBON DIOXIDE, DRY CHEMICAL, OR FOAM. AVOID USING WATER.
Fire Fighting Procedures: RECOMMEND SCBA. USE WATER ONLY FOR COOLING CONTAINER.
WATER MAY CAUSE SPLATTERING, OR TRANSPORT THE FLAME.
Unusual Fire/Explosion Hazard: SLIGHTLY COMBUSTIBLE. MAY RELEASE VAPORS WHEN
HEATED ABOVE FLASH POINT .
=======================================================
Control Measures
=======================================================
Respiratory Protection: USE NIOSH/MSHA APPROVED RESPIRATOR WITH ORGANIC VAPOR
CARTRIDGE AND DUST/MIST CARTRIDGE IS RECOMMENDED EXPOSURE LIMIT IS EXCEEDED.
SELF-CONTAINED BREATHING APPARATUS IS RECOMMENDED FOR CONFINED SPACEENTRY.
Ventilation: USE IN AREAS OF ADEQUATE VENTILATION. USE MECHANICAL EXHAUST TO
CONTROL VAPORS OR MISTS.
Other Protective Equipment: LONG SLEEVE SHIRT AND APRON WHEN POTENTIAL FOR SKIN
CONTACT. WEAR NEOPRENE OR NITRILE RUBBER BOOTS WHEN NECESSARY TO AVOID
CONTAMINATING SHOES.
Work Hygienic Practices: PRACTICE GOOD PERSONAL HYGIENE AFTER HANDLING.
Supplemental Safety and Health: ABBREVIATION: N/A = NOT APPLICABLE. N/AV = NOT
AVAILABLE. N/K = UNKNOWN. N/P = NOT PROVIDED. N/R = NOT RELEVANT. N/D = NOT
DETERMINED. N/E = NOT ESTABLISHED. CNS = CENTRAL NERVOUS SYSTEM. GI = GASTROI
NTESTINAL. SCBA = SELF CONTAINED BREATHING APPARATUS.
=======================================================
Physical/Chemical Properties
=======================================================
HCC: V6
NRC/State LIC No: NOT RELEVANT
Boiling Point: >300.C, 572.F
M.P/F.P Text: NOT PROVIDED
Decomp Text: NOT PROVIDED
Vapor Pres: < 0.01 MM HG@20C
Vapor Density: > AIR
Spec Gravity: 0.8640
Viscosity: NOT PROVIDED
Solubility in Water: NEGLIBIBLE
Appearance and Odor: SLIGHTLY YELLOW OIL, PETROLEUM ODOR
Percent Volatiles by Volume: NIL
Corrosion Rate: NOT PROVIDED
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: MATERIAL IS NORMALLY STABLE AT AMBIENT
TEMPERATURE AND PRESSURE.
Materials To Avoid: OXIDIZING AGENTS. DO NOT HEAT ABOVE THE FLASH POINT.
Hazardous Decomposition Products: CARBON MONOXIDE, CARBON DIOXIDE, AND
ASPHYXIANTS.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NONE
=======================================================
Toxicological Information
=======================================================
Toxicological Information: ORAL TOXICITY: SWALLOWING MATERIAL MAY CAUSE
IRRITATION OF THE GASTROINTESTINAL LINING, NAUSEA, VOMITING, DIARRHEA, AND
ABDOMINAL PAIN. EYE IRRITATION: NOT EXPECTED TO CAUSE EYE IRRITATION. SKIN
IRRIT ATION: NOT EXPECTED TO BE A PRIMARY SKIN IRRITANT. PROLONGED OR
REPETITIVE CONTACT MAY CAUSE IRRITATION. CARCINOGENIC: THIS MATERIAL HAS NOT
BEEN IDENTIFIED AS A CARCINOGEN BY NTP, IARC, OR OSHA.
=======================================================
Ecological Information
=======================================================
Ecological: THIS MATERIAL IS EXPECTED TO HAVE ADVERSE AFFECTS ON MARINE AND
PLANT LIFE. SPILLS MAY CONTAMINATE DRINKING WATER.
=======================================================
=======================================================
Transport Information: SEE 49 CFR PART 171.8 THROUGH 178.510. DOT SHIPPING
NAME: OIL, N.O.S. DOT HAZARD CLASS: NOT REGULATED UN/NA NUMBER: NA 1270.
GUIDE NUMBER: 27. IMDG CODE: NOT PROVIDED. MATERIALS CLASSIFIED AS DOT COM
BUSTIBLE LIQUIDS (FLASH POINT> 141F AND < 200F) ARE NOT REGULATED BY
DOT IN CONTAINERS OF 110 GALLONS, OR LESS FOR DOMESTIC SHIPMENTS.
=======================================================
Regulatory Information
=======================================================
Sara Title III Information: SARA 311: NOT PROVIDED. SARA 312: NOT PROVIDED.
SARA 313: NOT LISTED.
CERCLA: LISTED.
Federal Regulatory Information: TSCA: ALL COMPONENTS OF THIS MATERIAL ARE ON
THE US TSCA INVENTORY. RCRA: NOT LISTED.
State Regulatory Information: CAL PROP 65 NOT LISTED.
=======================================================
Other Information
=======================================================
Other Information: NONE
=======================================================
Transportation Information
=======================================================
Trans ID NO: 160164
Product ID: 19023, MIL-PRF-17672D GR 2110 TH
Review Date: 12/07/2001
Net Unit Weight: 396 LBS
Multiple KIT Number: 0
Unit Of Issue: DR
Container QTY: 1
Type Of Container: DRUM
Additional Data: NOT REGULATED FOR TRANSPORTATION, PER MSDS.
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: ZZZ
DOT Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: ZZZ
IMO Proper Shipping Name: NOT REGULATED FOR THIS MODE OF TRANSPORTATION
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: ZZZ
IATA Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: ZZZ
AFI Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
HAZCOM Label
=======================================================
Product ID: 19023, MIL-PRF-17672D GR 2110 TH
Cage: 8G974
Company Name: LUBRICATING SPECIALTIES CO
Street: 8015 PARAMOUNT BLVD
Zipcode: 90660
Label Required IND: Y
Date Of Label Review: 12/07/2001
Status Code: A
MFG Label NO: NOT PROVIDED
Label Date: 08/22/2001
Year Procured: 2002
Origination
Skin Protection IND: NO
Signal Word: CAUTION
Respiratory Protection IND: NO
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: CAUTION: TARGET ORGANS: EYES, SKIN, RESPIRATORY &
GI TRACT. AVOID PROLONGED OR REPEATED CONTACT WITH TARGET ORGANS. SHORT TERM
EXPOSURE IS NOT EXPECTED TO CAUSE ANY ADVERSE HEALTH EFFECTS. PROLONGED S KIN
CONTACT MAY CAUSE IRRITATION; WASH THOROUGHLY AFTER CONTACT. BREATHING
MIST/VAPORS MAY IRRITATE LUNGS. WEAR APPROPRIATE PROTECTIVE CLOTHING AND
RESPIRATORY DEVICES.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PEPPER FOG-CS SPECIAL
CAGE:4B498
CAGE:4B498
============= Composition/Information on Ingredients =============
Ingred Name:O-CHLOROBENZYLIDENE MALONONITRILE
CAS:2698-41-1
RTECS #:OO3675000
Other REC Limits:25,00 MG/CUM
OSHA PEL:S, C 0.05 PPM
ACGIH TLV:S, C 0.05 PPM; 9192
Ingred Name:CYCLOHEXANONE (SARA III)
CAS:108-94-1
RTECS #:GW1050000
Other REC Limits:N/K
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:GLYCERLY TRIACETATE.
CAS:102-76-1
RTECS #:AK3675000
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:N/K
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:N/K
Explanation of Carcinogenicity:N/K
Effects of Overexposure:EYES:IRRITATION,PROFUSE TEARING.SKIN:N/K
.INGESTION:THROAT IRRITATION,HEADACHE,NAUSEA AND
VOMITING,INHALATION:NOSE IRRITATION,HEADACHE,NAUSEA,AND VOMITING.
Medical Cond Aggravated by Exposure:N/K (F-N/ORNL)
======================= First Aid Measures =======================
First Aid:EYES:FLUSH WITH WATER FOR AT LEAST 15 MINUTES,CALL
PHYSICIAN.SKIN:WASH WITH SOAP AND WATER,CALL
PHYSICIAN,INGESTION:CONTACT PHYSICIAN.INHALATION:REMOVE TO FRESH
AIR.GIVE OXYGEN IF NECESSARY,CALL PHYSI CIAN.
===================== Fire Fighting Measures =====================
Flash Point:>116F,46C
Lower Limits:APPROX 1
Upper Limits:APPROX 8
Extinguishing Media:CARBON DIOXIDE,DRY CHEMICAL,OR FOAM.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:HAZARDOUS DECOMPOSITION PRODUCTS ARE
TOXIC FUMES.
================== Accidental Release Measures ==================
Spill Release Procedures:PICK UP MATERIAL WITH A SUITABLE ABSORBENT.
Neutralizing Agent:N/K
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY PLACE AWAY FROM
HEAT,SPARKS, AND OPEN FLAME.KEEP CONTAINERS CLOSED.
Other Precautions:N/K
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .TEAR GAS TYPE GAS MASK.
Ventilation:LOCAL AND GENERAL VENTILATION NECESSARY TO KEEP AIR
CONCENTRATION BELOW TLV .EXPLOSION-PROOF VENTILATION.
Other Protective Equipment:TYVEX COVERALLS.
Work Hygienic Practices:WEAR PROTECTIVE EQUIPMENT.WASH WITH SOAP AND
WATER,NO SMOKING.
Supplemental Safety and Health
AUTO-IGNITION TEMPERATURE:>790F,421C.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>150,302F
Melt/Freeze Pt:M.P/F.P Text:N/K
Decomp Temp:Decomp Text:N/K
Vapor Pres:>2 MMHG
Vapor Density:N/K
Spec Gravity:N/K
Evaporation Rate & Reference:N/K
Solubility in Water:LESS THAN 2%
Appearance and Odor:CLEAR ,IRRITATING.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:NO
ALKALI SOLUTIONS WILL REACT WITH THE CS.
Stability Condition to Avoid:N/K
Hazardous Decomposition Products:TOXIC FUMES
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH
FEDERAL,STATE AND LOCAL REGULATIONS .INCINERATE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:8889-404003,OHSPC000 ACATIONOX
CAGE:05963
CAGE:05963
============= Composition/Information on Ingredients =============
Ingred Name:ISOPROPANOL (ISOPROPYL ALCOHOL), 2-PROPANOL, DIMETHYL
CARBINOL
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: >30%
Other REC Limits:400 PPM
OSHA PEL:400 PPM
ACGIH TLV:400 PPM
Ingred Name:PLURONIC F68, SLOVANIK M-640, POLYOXYPROPYLENE GLYCOL
CAS:9003-11-6
RTECS #:MD0911050
Fraction by Wt: <70%
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(RAT): 5000 MG/KG PLURONIC L-64
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: IRRITATION. INHALATION: LIQUID
MISTS MAY BE IRRITATING. INGESTION: MODERATELY TOXIC.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, DIARRHEA, WEAKNESS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. GIVE CPR IF NEEDED. KEEP
WARM & QUIET. TREAT SYMPTOMATICALLY & SUPPORTIVELY. SKIN: WASH AREA
W/SOAP/MILD DETERGENT & LARGE AMOUNTS OF WATER FOR 15-20 MINS.
EYES: WASH W/LARGE AMOUNTS OF WATER/NORMAL SALINEFOR 15-20 MINS.
INGESTION: TREAT SYMPTOMATICALLY & SUPPORTIVELY. MAINTAIN AIRWAY &
RESPIRATION. KEEP HEAD BELOW HIPS TO PREVENT ASPIRATION IF VOMITING
OCCURS.
===================== Fire Fighting Measures =====================
Extinguishing Media:DRY CHEMICAL, CO2, WATER SPRAY/ALCOHOL-RESISTANT
FOAM. LARGE FIRES: WATER SPRAY, FOG/ALCOHOL-RESISTANT FOAM.
Fire Fighting Procedures:USE SCBA W/FULL FACE PIECE OPERATED IN A
PRESSURE DEMAND/OTHER POSITIVE PRESSURE MODE. MOVE CONTAINER
SAFELY. APPLY COOLING WATER TO SIDES OF CONTAINERS. (SUPP)
Unusual Fire/Explosion Hazard:THE FIRE HAZARD FOR THIS PRODUCT HASN'T
BEEN DETERMINED.
================== Accidental Release Measures ==================
Spill Release Procedures:SHUT OFF IGNITION SOURCES. STOP LEAK SAFELY.
USE WATER SPRAY TO REDUCE VAPORS. SMALL: TAKE UP W/ABSORBENT
MATERIAL & PLACE IN FLARES INTO CONTAINERS FOR LATER DISPOSAL.
LARGE: DIKE FAR AHEAD. NO SMOKI NG, FLAME S/FLARES IN HAZARD AREA.
ISOLATE AREA.
======================Handling and Storage ======================
Handling and Storage Precautions:SUBSTANCES W/LOW ELECTROCONDUCTIVITY,
MAY BE IGNITED BY ELECTROSTATIC SPARKS, WHICH SHOULD BE STORED IN
CONTAINERS TO MEET BONDING/GROUNDING GUIDELINE
Other Precautions:STORE AWAY FROM INCOMPATIBLE SUBSTANCES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE ANY NIOSH/MSHA APPROVED CHEMICAL CARTRIDGE
RESPIRATOR W/ORGANIC VAPOR CARTRIDGES & A FULL FACEPIECE; GAS MASK
W/ORGANIC VAPOR CANISTER (CHIN-STYLE/FRONT/BACK-MOUNTED
CANISTER)W/A FULL FACEPIECE.
Ventilation:GENERAL DILUTION TO MEET EXPOSURE LIMITS. EQUIPMENT MUST BE
EXPLOSION-PROOF.
PROTECTIVE (IMPERVIOUS) CLOTHING, EYE WASH FOUNTAIN.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING & SHOES
BEFORE REUSE.
Supplemental Safety and Health
FIRST AID CONT'D: OBTAIN MEDICAL ATTENTION IN ALL CASES.
================== Physical/Chemical Properties ==================
Appearance and Odor:LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
PLUROMIC L-64: STRONG OXIDIZERS
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY INCLUDE
TOXIC OXIDES OF CARBON.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS. EPA HAZARDOUS WASTE NO D001.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:161 9709 PAGI-SET RC PAPER DEVELOPER AND REPLENISHER
CAGE:19139
CAGE:19139
CAGE:5K871
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 60-65%
Other REC Limits:NONE RECOMMENDED
Ingred Name:POTASSIUM SULFITE
CAS:10117-38-1
RTECS #:WT3530000
Fraction by Wt: 20-25%
Other REC Limits:NONE RECOMMENDED
Ingred Name:POTASSIUM CARBONATE
CAS:584-08-7
RTECS #:TS7750000
Fraction by Wt: 5-10%
Other REC Limits:NONE RECOMMENDED
Ingred Name:HYDROQUINONE (SARA 302/313) (CERCLA)
CAS:123-31-9
RTECS #:MX3500000
Fraction by Wt: 4%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3; 9596
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:DIETHYLENE GLYCOL
CAS:111-46-6
RTECS #:ID5950000
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:HYDROXYMETHYL-4-METHYL-1-PHENYL-3-PYRAZOLIDONE
CAS:13047-13-7
Fraction by Wt: < 1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM HYDROXIDE (CERCLA)
CAS:1310-73-2
RTECS #:WB4900000
Fraction by Wt: < 1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:2 MG/M3
ACGIH TLV:C 2 MG/M3; 9596
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT): NOT GIVEN
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EXPECTED TO BE A LOW INHALATION HAZARD
FOR RECOMMENDED HANDLING. MAY LIBERATE SULFUR DIOXIDE GAS WHICH IS
IRRITATING TO RESPIRATORY TRACT. EYE CONTACT CAUSES IRRITATION.
SKIN CONTACT CAUSES IRRITATION ; MAY CAUSE ALLERGIC SKIN REACTION.
HARMFUL IF SWALLOWED. MAY CAUSE IRRITATION OF GI TRACT.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:EYE IRRITATION, SKIN IRRITATION, ALLERGIC SKIN
REACTION, RESPIRATORY TRACT IRRITATION, GI TRACT IRRITATION,
DIFFICULT BREATHING, WHEEZING, CHEST TIGHTNESS, STOMACH UPSET,
HIVES, FAINTNESS, WEAKNESS, D IARRHEA.
Medical Cond Aggravated by Exposure:WOME ASTHMATICS OR
SULFITE-SENSITIVE INDIVIDUALS MAY EXPERIENCE WHEEZING, CHEST
TIGHTNESS, STOMACH UPSET, HIVES, FAINTNESS, WEAKNESS, DIARRHEA.
======================= First Aid Measures =======================
First Aid:INHALATION: IF SYMPTOMATIC, MOVE TO FRESH AIR. GET MEDICAL
ATTENTION IF SYMPTOMS PERSIST. EYES: WASH OUT IMMEDIATELY WITH
WATER. GET MEDICAL ATTENTION IF SYMPTOMS OCCUR. SKIN: WASH WITH
SOAP AND WATER . GET MEDICAL ATTENTION IF SYMPTOMS OCCUR.
INGESTION: ONLY INDUCE VOMITING AT THE INSTRUCTION OF MEDICAL
PERSONNEL. CALL PHYSICIAN OR POISON CONTROL ASAP. NEVER GIVE
ANYTHING BY MOUTH IF UNCONSCIOUS.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:NONFLAMMABLE. USE EXTINGUISHING MEDIA SUITABLE FOR
SURROUNDING FIRE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING. FIRE OR EXCESSIVE HEAT MAY PRODUCE HAZARDOUS
DECOMPOSITION PRODUCTS.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH TO SEWER IF ALLOWABLE WITH LARGE AMOUNTS
OF WATER. OTHERWISE, ABSORB SPILL WITH VERMICULITE OR OTHER INERT
MATERIAL, THEN PLACE IN A CONTAINER FOR CHEMICAL WASTE. CLEAN
SURFACE TO REMOVE RESIDUA L CONTAMINATION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID BREATHING MIST OR VAPOR. AVOID
CONTACT WITH EYES, SKIN & CLOTHING. USE WITH ADEQUATE VENTILATION.
KEEP CONTAINER TIGHTLY CLOSED.
Other Precautions:THE ROUTINE USE OF A NONALKALINE (ACID) TYPE OF HAND
CLEANER AND REGULAR CLEANING OF WORKING SURFACES WILL HELP MINIMIZE
THE POSSIBILITY OF A SKIN REACTION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED. A RESPIRATOR SHOULD BE
WORN IF HAZARDOUS DECOMPOSITION PRODUCTS ARE LIKELY TO BE OR HAVE
BEEN RELEASED. RESPIRATOR TYPE: ACID GAS. IF RESPIRATORS ARE USED,
A PROGRAM SHOULD BE I NSTITUTED.
Ventilation:GOOD GENERAL VENTILATION, TYPICALLY 10 AIR CHANGES PER
HOUR, SHOULD BE USED. RATES SHOULD MATCH CONDITIONS.
Other Protective Equipment:CHEMICAL RESISTANT CLOTHING AS NECESSARY TO
PREVENT SKIN CONTACT. AN EMERGENCY EYEWASH AND SHOWER SHOULD BE
AVAILABLE.
Work Hygienic Practices:WASH HANDS THOROUGHLY WITH SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES.
Supplemental Safety and Health
REMOVE AND WASH CONTAMINATED CLOTHING BEFORE REUSE.
================== Physical/Chemical Properties ==================
HCC:B3
Boiling Pt:B.P. Text:>212F,>100C
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Decomp Temp:Decomp Text:NOT GIVEN
Vapor Pres:18
Vapor Density:0.6
Spec Gravity:1.31
pH:10.6
Viscosity:NOT GIVEN
Evaporation Rate & Reference:NOT GIVEN
Solubility in Water:COMPLETE
Appearance and Odor:LIGHT AMBER LIQUID, NO ODOR
Percent Volatiles by Volume:60%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
SULFUR DIOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT OR DISPOSAL MAY BE SUBJECT
TO NATIONAL, STATE OR LOCAL LAWS. MAY REQUIRE NEUTRALIZATION IF PH
< 2.0 OR PH > 12.5. DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE ANDLOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:DUNCAN MASK'N PEEL SY 548
Preparer's Name:SCOTT MATTISON
CAGE:21546
CAGE:21546
============= Composition/Information on Ingredients =============
Ingred Name:AMMONIA, AMMONIUM HYDROXIDE-ANHYDROUS, ANHYDROUS AMMONIA
CAS:7664-41-7
RTECS #:BO0875000
Other REC Limits:25 PPM
OSHA PEL:50 PPM
ACGIH TLV:25 PPM
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:AMMONIA CAUSES REVERSIBLE EYE & THROAT
IRRITATION & RESPIRATORY DISTRESS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:AMMONIA CAUSES REVERSIBLE EYE & THROAT
IRRITATION & RESPIRATORY DISTRESS.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR 15 MINS. SKIN: WASH W/SOAP & WATER.
INHALATION: REMOVE TO FRESH AIR. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER, CO2/DRY CHEMICAL
Fire Fighting Procedures:WEAR SCBA APPROVED BY NIOSH. USE WATER SPRAY
TO KEEP CONTAINERS COOL, KEEP SPILLAGE AWAY FROM FIRE & HEAT & TO
KNOCK DOWN VAPORS.
Unusual Fire/Explosion Hazard:BURNING DRY LATEX CREATES DENSE, BLACK
SMOKE W/THE POTENTIAL FOR TOXIC VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:CONFINE AREA TO PREVENT CONTAMINATION OF SEWER
SYSTEM OF GROUND WATER. ABSORB LIQUID ONTO AN APPROPRIATE
ABSORBENT. AREA WILL CAUSE SLIPPERY CONDITIONS.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID EXTREME TEMPS. KEEP FROM
FREEZING. KEEP SEALED.
Other Precautions:KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHEN PERMISSIBLE EXPOSURE LIMITS ARE EXCEEDED,
USE MASK SUPPLIED W/EXTERNAL AIR/OTHER NIOSH APPROVED RESPIRATORY
PROTECTION.
Ventilation:LOCAL EXHAUST RECOMMENDED. MECHANICAL (GENERAL):
RECOMMENDED WHEN SPRAYING. USE RESPIRATOR WHEN SPRAYING.
Other Protective Equipment:SAFETY SHOWER/EYE WASH STATIONS.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F
Spec Gravity:0.96
pH:9.5-10
Evaporation Rate & Reference:(BU AC = 1): 1
Appearance and Odor:CREAM COLORED LIQUID W/SLIGHT AMMONIA ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
SOLVENTS, ACIDS, METAL SALTS, OTHER COMPOUNDS.
Stability Condition to Avoid:EXTREME TEMPS, FREEZING.
Hazardous Decomposition Products:THERMAL: TOXIC GASES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:7006S CHROMA ONE & CHROMA ONE
Preparer's Name:T R LOUER
CAGE:23027
CAGE:90227
CAGE:23027
============= Composition/Information on Ingredients =============
Ingred Name:ALIPHATIC POLYISOCYANATE, HEXAMETHYLENE DIISOCYANATE
POLYMER *96-2*
CAS:3779-63-3
Ingred Name:OXO-HEXYL ACETATE *96-2*
CAS:88230-35-7
Ingred Name:PROPYLENEGLYCOL MONOMETHYL ETHER ACETATE,
1-METHOXY-2-PROPANOL ACETATE
CAS:108-65-6
RTECS #:AI8925000
Ingred Name:HEXAMETHYLENE DIISOCYANATE
CAS:822-06-0
RTECS #:MO1740000
Fraction by Wt: 0.2%
ACGIH TLV:0.005 PPM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:VOLATILE ORGANIC CONTENT: 2.4 LBS/GAL
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: MAY CAUSE NOSE & THROAT
IRRITATION. EXPOSURE TO ISOCYANATES MAY CAUSE RESPIRATORY
SENSITIZATION & MAY CAUSE A DECREASE IN LUNG FUNCTION WHICH MAY BE
PERMANENT. EYES: IRRITATION/BURNING. SK IN: IRRITATION &
DERMATITIS. REPEATED/PROLONGED OVEREXPOSURE TO SOLVENTS MAY CAUSE
PERMANENT BRAIN & CNS DAMAGE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:GI DISTRESS, IRRITATION, EYE WATERING,
HEADACHES, NAUSEA, DIZZINESS, LOSS OF COORDINATION, BURNING,
DISCOMFORT.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. EYES: FLUSH W/PLENTY OF
WATER FOR 15 MINS. SKIN: WASH W/SOAP & WATER. OBTAIN MEDICAL
ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:>100F
Lower Limits:0.8
Upper Limits:23
Extinguishing Media:WATER SPRAY, FOAM, CO2, DRY CHEMICAL.
Fire Fighting Procedures:USE FULL PROTECTIVE EQUIPMENT & SCBA. WATER
FROM FOG NOZZLES MAY BE USED TO COOL CLOSED CONTAINERS.
Unusual Fire/Explosion Hazard:WHEN HEATED > THE FLASH POINT, EMITS
FLAMMABLE VAPORS, WHEN MIXED W/AIR CAN BURN/BE EXPLOSIVE. FINE
MISTS/SPRAYS MAY BE FLAMMABLE AT TEMPS < THE FLASH POINT.
================== Accidental Release Measures ==================
Spill Release Procedures:DON'T BREATHE VAPORS. DON'T GET IN EYES/ON
SKIN. WEAR A POSITIVE PRESSURE SUPPLIED AIR VAPOR/PARTICULATE
RESPIRATOR(NIOSH/MSHA TC-19C)& PROTECTIVE MATERIAL. REMOVE SOURCES
OF IGNITION. ABSORB W/INERT MATERIAL. VENTILATE AREA. (SEE SUPP)
Neutralizing Agent:DECONTAMINATION SOLUTIONS: 20% SURFACTANT (TERGITOL
TMN 10), 80% WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS & FLAME.
CLOSE CONTAINER AFTER EACH USE. GROUND CONTAINERS WHEN POURING.
DON'T STORE >120F. OBSERVE LABEL PRECAUTIONS.
Other Precautions:DON'T SAND, FLAME CUT, BRAZE/WELD DRY COATING W/O A
NIOSH/MSHA APPROVED RESPIRATOR/APPROPRIATE VENTILATION. DON'T
BREATHE VAPORS. DON'T PERMIT ANYONE W/O PROTECTION IN THE PAINTING
AREA.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR A POSITIVE PRESSURE SUPPLIED AIR
RESPIRATOR(NIOSH/MSHAT TC-19C)DURING APPLICATION. INDIVIDUALS W/A
HISTORY OF LUNG/BREATHING PROBLEMS/REACTION TO ISOCYANATES
SHOULDN'T USE/BE EXPOSED TO PRODUCT.
Ventilation:SUFFICIENT IN VOLUME & PATTERN TO KEEP CONTAMINANTS BELOW
APPLICABLE OSHA LIMITS.
Other Protective Equipment:COVERALLS.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING & BEFORE
EATING/SMOKING.
Supplemental Safety and Health
PERCENT VOLATILE BY VOLUME: 31.8-86.3%. SPILLS: POUR LIQUID
DECONTAMINATION SOLUTION OVER THE AREA & ALLOW TO SIT 10 MINS,
MINIMUM. THIS PROCEDURE CAN GENERATE PRESSURE. DON'T SEAL
CONTAINERS. AFTER 4 8 HOURS, SEAL CONTAINER & DISPOSE OF MATERIAL.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:169-415F
Vapor Density:>1
Evaporation Rate & Reference:LESS THAN AIR
Solubility in Water:MISCIBLE
Percent Volatiles by Volume:(SUPP)
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE REASONABLY FORESEEABLE.
Stability Condition to Avoid:HEAT, SPARKS, FLAME, TEMPS >120F.
Hazardous Decomposition Products:CO, CO2, SMOKE.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE/DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS. DON'T ALLOW MATERIAL TO CONTAMINATE GROUND WATER
SYSTEMS. DON'T INCINERATE IN CLOSED CONTAINERS. FLAMMABLE LIQUID
UN1263.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PRIMER COATING, EXTERIOR BROWN, 20400 BROW
CAGE:33200
CAGE:33200
============= Composition/Information on Ingredients =============
Ingred Name:ALKYD RESIN
Fraction by Wt: 25%
Ingred Name:PETROLEUM DISTILLATES (NAPHTHA OR RUBBER SOLVENT)
CAS:8002-05-9
RTECS #:SE7449000
Fraction by Wt: 23%
OSHA PEL:400 PPM
ACGIH TLV:400 PPM; 8990
===================== Hazards Identification =====================
Effects of Overexposure:PRODUCES SEVERE EYE IRRITATION, DRYING OF SKIN.
EXCESSIVE INHALATION CAUSES HEADACHES, DIZZINESS
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER. SKIN: WASH WITH MILD SOAP AND WATER
AND APPLY SKIN CREAM. INHALATION: REMOVE TO FRESH AIR AND CALL A
PHYSICIAN. APPLY ARTIFICAL RESPIRATION IF NECESSARY.
===================== Fire Fighting Measures =====================
Flash Point:102F, SETA
Lower Limits:0.8
Upper Limits:5.0
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL
Fire Fighting Procedures:TREAT AS CLASS B FIRE
Unusual Fire/Explosion Hazard:VAPORS MAY FORM EXPLOSIVE MIXTURES WITH
AIR.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR A RESPIRATOR. FLUSH WITH WATER INTO
RETAINING AREA OR CONTAINER. AVOID EXPOSUREO SPARKS, FIRE OR HOT
METAL SURFACES.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS, OPEN
FLAME. USE WITH ADEQUATE VENTILATION. AVOID PROLONGED OR REPTED
SKIN CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SELF-CONTAINED NIOSH APPROVED RESPIRATOR IF TLV
IS EXCEEDED
Ventilation:LOCAL EXHAUST
Other Protective Equipment:EYE BATH AND SAFETY SHOWER
Supplemental Safety and Health
808 OLD COUNTRY ROAD, EDGEWATER, FLA. 32032.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:315F
Vapor Pres:<80
Vapor Density:4.9
Spec Gravity:1.43
Evaporation Rate & Reference:0.1, BUAC=1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BROWN OPAQUE LIQUID, PETROLEUM DISTILLATE ODOR
Percent Volatiles by Volume:39
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Stability Condition to Avoid:EXCESSIVE HEAT, SPARKS AND OPEN FLAMES
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY YIELD CARBON
MONOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:LANDFILL, INCINERATION UNDER SAFE AND SUPERVISED
CONDITIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SNOWDRIFT MASONS LIME
CAGE:GO213
CAGE:0GRK9
CAGE:GO213
============= Composition/Information on Ingredients =============
Ingred Name:CALCIUM HYDROXIDE, LIME, CALCIUM HYDRATE
CAS:1305-62-0
RTECS #:EW2800000
Fraction by Wt: 100%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:5 MG/M3; 9293
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION & CORROSION DAMAGE.
SKIN: IRRITATION & BURNS. INHALATION: UPPER RESPIRATORY TRACT
IRRITATION, & MUCOUS MEMBRANE DAMAGE. INGESTION: DIGESTIVE TRACT
CORROSION.
Explanation of Carcinogenicity:NONE
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR 15 MINS, INCLUDING UNDER LIDS. SKIN:
WASH W/PLENTY OF WATER. INHALATION: REMOVE TO FRESH AIR. INGESTION:
DILUTE BY GIVING 2 GLASSES OF MILK OR WATER TO DRINK, FOLLOWED BY
FRUIT JUICES OR DILUTED VINEGAR TO NEUTRALIZE THE ALKALI. OBTAIN
MEDIAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:NOT COMBUSTIBLE
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS NIOSH
APPROVED.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PERSONAL PROTECTION. KEEP SPILLED
MATERIAL AWAY FROM ACIDS. CAREFULLY PICK UP SOLID W/A MINIMUM OF
DUSTING & COLLECT IN METAL CONTAINERS W/COVERS FOR DISPOSAL. TRACE
AMOUNTS OF RESIDUE IN SPILL A REA CAN BE FLUSHED TO DRAIN USING
PLENTY WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE MATERIAL IN SEALED CONTAINERS IN
DRY PLACE, AWAY FROM ACIDS. PROTECT CONTAINERS AGAINST PHYSICAL
DAMAGE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE APPROVED DUST RESPIRATOR WHEN DUSTY
CONDITION EXISTS
Ventilation:GENERAL & LOCAL EXHAUST TO MEET TLV REQUIREMENTS FOR LIME
DUST. MECHANICAL EXHAUST: SUFFICIENT IN ABSENCE OF DUST/MIST.
Other Protective Equipment:DRY RUBBER BODY-COVERING PROTECTIVE
CLOTHING, EYE WASH STATION & SAFETY SHOWER
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:2850C
Spec Gravity:2.2-2.6
pH:11.7
Solubility in Water:0.1 G/100G
Appearance and Odor:WHITE POWDER W/LOW ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
BORIC OXIDE, ACIDS, FLUORINE, ORGANIC MATERIALS
==================== Disposal Considerations ====================
Waste Disposal Methods:ADD TO WATER, DILUTE & FLUSH TO SEWER (LARGE
AMOUNTS MAY REQUIRE NEUTRALIZATION BY ACID) IN ACCORDANCE
W/FEDERAL, STATE, & LOCAL REGULATIONS. ALTERNATELY, WASTE LIME CAN
BE USED FOR NEUTRALIZING PLANT ACID WASTE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:N40B100, SILICONE ALKYD COPOLYMER
Preparer's Name:ERNEST CARTER
CAGE:54636
CAGE:54636
============= Composition/Information on Ingredients =============
Ingred Name:MINERAL SPIRITS
CAS:64742-88-7
Code:F
Minumum % Wt:5.
Maxumum % Wt:20.
OSHA PEL:100 PPM
ACGIH TLV:100
Ingred Name:TOLUENE
CAS:108-88-3
RTECS #:XS5250000
Minumum % Wt:.5
Maxumum % Wt:1.
OSHA PEL:SEE TABLE Z-2
ACGIH TLV:188 MG/M3;50 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:XYLENE
CAS:1330-20-7
RTECS #:ZE2100000
Minumum % Wt:.5
Maxumum % Wt:1.
OSHA PEL:100 PPM
ACGIH TLV:434 MG/M3;100 PPM
ACGIH STEL:651 MG/M3;150 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:LIGHT AROMATIC SOLVENT NAPHTHA (PETROLEUM)
CAS:64742-95-6
RTECS #:WF3400000
Minumum % Wt:1.
Maxumum % Wt:5.
Ingred Name:1,3,5-TRIMETHYLBENZENE
CAS:108-67-8
RTECS #:OX6825000
Minumum % Wt:1.
Maxumum % Wt:5.
OSHA PEL:25 PPM
ACGIH TLV:25 PPM
Ingred Name:1,2,4-TRIMETHYLBENZENE
CAS:95-63-6
RTECS #:DC3325000
Minumum % Wt:3.
Maxumum % Wt:8.
OSHA PEL:25 PPM
ACGIH TLV:25 PPM
Ingred Name:COBALTOUS 2-ETHYLHEXANOATE
CAS:136-52-7
Minumum % Wt:.1
Maxumum % Wt:.2
Ingred Name:1-METHOXY-2-PROPANOL ACETATE, 108-67-8
Minumum % Wt:1.
Maxumum % Wt:5.
Ingred Name:KAOLIN
CAS:1332-58-7
RTECS #:GF1670500
Minumum % Wt:0.
Maxumum % Wt:10.
OSHA PEL:15 MG/M3
ACGIH TLV:2 MG/M3
Ingred Name:TALC
CAS:14807-96-6
RTECS #:WW2710000
Minumum % Wt:0.
Maxumum % Wt:5.
OSHA PEL:SEE TABLE Z-3
ACGIH TLV:2 MG/M3
Ingred Name:CALCIUM CARBONATE
CAS:471-34-1
RTECS #:FF9335000
Minumum % Wt:5.
Maxumum % Wt:15.
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Minumum % Wt:0.
Maxumum % Wt:30.
OSHA PEL:15 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Minumum % Wt:0.
Maxumum % Wt:5.
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:EXPOSURE MAY BE BY INHALATION AND/OR
SKIN OR EYE CONTACT, DEPENDING ON CONDITIONS OF USE. TO MINIMIZE,
FOLLOW RECOMMENDATIONS FOR PROPER USE, VENTILATION,AND PERSONAL
PROTECTIVE EQUIPMENT.IRRITATION O F EYES, SKIN AND RESPIRATORY
SYSTEM. MAY CAUSE NERVOUS SYSTEM DEPRESSION.EXTREME OVEREXPOSURE
MAY RESULT IN UNCONSCIOUSNESS AND POSSIBLY DEATH.
Effects of Overexposure:HEADACHE,DIZZINESS,NASEA,AND LOSS OF
COORDINATION ARE INDICATIONS OF EXCESSIVE EXPOSURE TO VAPORS OR
SPRAY MISTS.REDNESS AND ITCHING OR BURING SENSATION MAY INDICATE
EYE OR EXCESSIVE SKIN EXPOSURE.
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.
======================= First Aid Measures =======================
First Aid:IF AFFECTED, REMOVE FROM EXPOSURE. RESTORE BREATHING. KEEP
WARM AND QUIET. WASH AFFECTED AREA THOROUGHLY WITH SOAP AND WATER.
REMOVE COMTAMINATED CLOTHING AND LAUNDER BEFORE RE-USE. FLUSH EYES
WITH LA RGE AMOUNTS OF WATER FOR 15 MINUTES. GET MEDICAL ATTENTION.
GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:CALC
Flash Point:=37.8C, 100.F
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM
Fire Fighting Procedures:FULL PROTECTIVE EQUIPMENT INCLUDING
SELF-CONTAINED BREATHING APPARATUS SHOULD BE USED. WATER SPRAY MAY
BE INEFFECTIVE. IF WATER IS USED, FOG NOZZLES ARE PREFERABLE. WATER
MAY BE USED TO COOL CLOSED CO NTAINERS TO PREVENT PRESSURE BUILD-UP
AND POSSIBLE AUTOIGNITION OR EXPLOSION WHEN EXPOSED TO EXTREME
HEAT.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE
FROM HEAT, ELECTRICAL EQUIPMENT, SPARKS, AND OPEN FLAME. CLOSED
CONTAINERS MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT.APPLICATION TO
HOT SURFACES REQUIRES SPECIAL PRECAUTIONS.DURING EMERGENCY
CONDITIONS OVEREXPOSURE TO DECOMPOSITION PRODUCTS MAY CAUSE A
HEALTH HAZARD.L ATTENTION.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
======================Handling and Storage ======================
Handling and Storage Precautions:CONTENTS ARE COMBUSTIBLE. KEEP AWAY
FROM HEAT AND OPEN FLAME. CONSULT NFPA CODE. USE APPROVED BONDING
AND GROUNDING. BROCEDURES. KEEP CONTAINER CLOSED WHEN NOT IN USE.
TRANSFER ONLY TO APPROVED CONTAI NERS WITH COMPLETE AND APPROPRIATE
LABELING. DO NOT TEKE INTERNALLY. KEEP OUT OF REACH OF CHILDREN.
Other Precautions:INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING AND
INHALING THE CONTENTS CAN BE HARMFUL OR FATAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF PERSONAL EXPOSURE CANNOT BE CONTROLLED BELOW
APPLICABLE LIMITS BY VENTILATION.WEAR A PROPERLY FITTED ORGANTIC
VAPOR/PARTICULATE RESPIRATOR APPROVED BY NIOSH/MSHA FOR PROTECTION
AGAINST MATERIALS. W HEN SANDING OR ABRDING THE DRIED FILM, WEAR A
DUST/MIST RESPIRATOR UNDERLYING PAINT, OR THE ABRASIVE.
Ventilation:LOCAL EXHAUST PREFERABLE. GENERAL EXHAUST ACCEPTABLE IF THE
EXPOSURE TO MATERIALS IN SECTION11 IS MAINTAINED BELOW APPLICABLE
EXPOSURE LIMITS.
FOR PROTECTION.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:281-395
Vapor Density:HEAVIER
Spec Gravity:1.1-1.4
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:35-45
================= Stability and Reactivity Data =================
Hazardous Decomposition Products:BY FIRE: CARBON DIOXIDE, CARBON
MONOXIDE
Conditions to Avoid Polymerization:WILL NOT OCCUR
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE FROM THIS PRODUCT MAY BE HAZARDOUS AS
DEFINED UNDER THE RESOURCE CONSERVATION AND RECOVERY ACT (RCRA) 40
CFR 261. WASTE MUST BE TREATED FOR IGNITABILITY TO DETERMINE THE
APPLICABLE EPA HAZARDOUS WASTE NUMBERS.
===================== Regulatory Information =====================
SARA Title III Information:108-88-3, TOLUENE, 1% MAX; 1330-20-7,
XYLENE, 1% MAX; 95-63-6, 1,2,4-TRIMETHYLBENZENE, 8% MAX.; COBALT
COMPOUND, .2% BY WEIGHT.
State Regulatory Information:SARA 313 (40 CFR 372.65 C) SUPPLIER
NOTIFICATION
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CREATINE KINASE ISOENZYME VERIFIER
CAGE:63404
CAGE:63404
============= Composition/Information on Ingredients =============
Ingred Name:HUMAN SERUM
Other REC Limits:NONE RECOMMENDED
Ingred Name:CREATINE KINASE
Fraction by Wt: < 1%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:TLV 5 MG/M3
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION MAY PROVOKE RESPIRATORY
ALLERGY. SKIN SENSITIZATION CAN OCCUR. ALLERIC REACTION CAN PRODUCE
CONTACT DERMATITIS OR ECZEMA. ALLERGIC REACTION CAN PRODUCE EYE
IRRITATION. INGESTION MAY CAUSE B IOLOGICAL INFECTION/ALLERGIC
RASH. INFECTION WITH INFECTIOUS DISEASE AGENTS IS POSSIBLE FROM
EXPOSURE TO THIS MATERIAL.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:RESPIRATORY IRRITATION, HAY FEVER, ASTHMA, SKIN
IRRITATION, DERMAITIS, INFLAMMATION OF SKIN, REDNESS, ICHTING,
WEEPING, OOZING, CRUSTING OF THE SKIN, EYE IRRITATION, ITCHING
REDNESS, SWELLING OF TISSU E AROUND THE EYES, RASH.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR 15 MINUTES WHILE HOLDING EYELIDS
OPEN. GET MEDICAL ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING.
WASH WITH SOAP AND WATER. IF IRRITATION PERSISTS, GET MEDICAL
ATTENTION. IN HALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. GET
MEDICAL ATTENTION. INGESTION: GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:WATER FOG, WATER SPRAY, WATER, DRY CHEMICAL, CARBON
DIOXIDE, DRY POWDER (SAND OR MET-L-X).
Fire Fighting Procedures:NONE SPECIFIED BY MANUFACTURER.
Unusual Fire/Explosion Hazard:DUST FORMS EXPLOSIVE MIXTURE WITH AIR.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROPER PERSONAL PROTECTIVE EQUIPMENT. PUT
IN BIOHAZARD BAG. WIPE UP RESIDUE WITH PAPER TOWELS AND 20% COLOROX
SOLUTION. PUT PAPER TOWELS IN BIOHAZARD BAG. AUTOCLAVE. DISPOSE OF
PROPERLY.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS AND
FLAMES. IF THE LYOPHILIZED PRODUCT IS REMOVED FROM THE VIAL, AVOID
DUST GENERATION AND TREAT AS RESPIRATORY SENSITIZER
Other Precautions:AVOID SKIN CONTACT. LAUNDER CONTAMINATED CLOTHING
BEFORE REUSE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NORMALLY REQUIRED.
Ventilation:LOCAL EXHAUST AND MECHANICAL (GENERAL) VENTILATION TO
MAINTAIN EXPOSURE LEVELS.
Other Protective Equipment:PROTECTIVE CLOTHING AS REQUIRED TO AVOID
SKIN CONTACT. AN EMERGENCY EYE WASH STATION AND SHOWER SHOULD BE
AVAILABLE.
Work Hygienic Practices:WASH WITH SOAP AND WATER AFTER HANDLING PRODUCT
AND BEFORE EATING DRINKING OR SMOKING.
Supplemental Safety and Health
DO NOT BREATHE DUST. AVOID CONTACT WITH EYES. AVOID CONTACT WITH SKIN.
USE GERMICIDAL SOAP TO WASH SKIN.
================== Physical/Chemical Properties ==================
HCC:T6
Boiling Pt:B.P. Text:NOT GIVEN
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Vapor Pres:NOT GIVEN
Vapor Density:NOT GIVEN
Spec Gravity:NOT GIVEN
Evaporation Rate & Reference:NOT GIVEN
Solubility in Water:SOLUBLE
Appearance and Odor:WHITE POWDER, NO ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:GENERATION OF DUST.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:PLACE IN BIOHAZARD BAG AND AUTOCLAVE. DISCARD
ANY PRODUCT, RESIDUE, DISPOSAL CONTAINER OR LINER IN ACCORDANCE
WITH ALL FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:HYDROCHLORIC ACID
CAGE:DO870
CAGE:DO870
CAGE:70829
============= Composition/Information on Ingredients =============
Ingred Name:HYDROGEN CHLORIDE (HYDROCHLORIC ACID) (SARA III)
CAS:7647-01-0
RTECS #:MW4025000
Fraction by Wt: 33-40%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:C 5 PPM
ACGIH TLV:C 5 PPM; 9394
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 60-67%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION- PULMONARY EDEMA,
CIRCULATORY FAILURE, RESPIRATORY SYSTEM DAMAGE/COLLAPSE. SKIN AND
EYES- SEVERE BURNS. INGESTION- MAY BE FATAL, SEVERE BURNS TO
MOUTH, THROAT, AND STOMACH.
Effects of Overexposure:INHALATION- COUGHING AND DIFFICULT BREATHING.
INGESTION- NAUSEA AND VOMITING.
Medical Cond Aggravated by Exposure:NONE IDENTIFIED.
======================= First Aid Measures =======================
First Aid:INGESTION- CALL A PHYSICIAN. DO NOT INDUCE VOMITING. IF
CONSCIOUS, GIVE WATER, MILK, OR MILK OF MAGNESIA. INHALATION-
REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE ARTIFICIAL RESPIRATION.
IF BREATHING I S DIFFICULT, GIVE OXYGEN. SKIN AND EYES- IMMEDIATELY
FLUSH WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES. REMOVING
CONTAMINATED CLOTHING AND SHOES. WASH CLOTHING BEFORE REUSE.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE ANY MEDIA FOR SURROUNDING FIRE
Fire Fighting Procedures:FIREFIGHTERS SHOULD WEAR PROPER PROTECTIVE
EQUIPMENT AND SELF-CONTAINED BREATHING APPARATUS WITH FULL
FACEPIECE OPERATED IN POSITIVE PRESSURE MODE.
Unusual Fire/Explosion Hazard:MOVE CONTAINERS FROM FIRE AREA IF IT CAN
BE DONE WITHOUT RISK. USE WATER TO KEEP FIRE-EXPOSED CONTAINERS
COOL. DO NOT GET WATER INSIDE CONTAINERS. TOXIC GASES.
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION;VENTILATE THE
AREA;NEUTRALIZE SPILL WITH SODA ASH OR LIME AND RECOVER;FLUSH SPILL
AREA WITH WATER AND RECOVER ALL FOR PROPER DISPOSAL.
Neutralizing Agent:SODA ASH OR LIME. J.T. BAKER NEUTRASORB(R) OR
TEAM(R) 'LOW NA+' NEUTRALIZERS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY AND IN CORROSION
PROOF AREA;KEEP CONTAINER TIGHTLY CLOSED.DO NOT STORE NEAR
OXIDIZING MATERIALS.
Other Precautions:AVOID CONTACT WITH SKIN AND EYES.USE PROPER
PROTECTION. DO NOT USE CONTAMINATED CLOTHES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR FOR ACID MIST
OR HCL GAS
Ventilation:LOCAL EXHAUST TO MAINTN BELOW TLV.
Other Protective Equipment:FULL PROTECTIVE CLOTHING,SAFETY SHOWER,EYE
WASH STATION
Supplemental Safety and Health
MSDS DATED 03/12/86
================== Physical/Chemical Properties ==================
HCC:C1
Boiling Pt:B.P. Text:300F,149C
Melt/Freeze Pt:M.P/F.P Text:-13F,-25C
Vapor Density:1.3
Spec Gravity:1.18
pH:1.0*
Solubility in Water:100%
Appearance and Odor:CLEAR, COLORLESS FUMING LIQUID, PUNGENT ODOR.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
COMMON METALS,WATER,STRONG BASES,AMINES,CO3,METAL OXIDES
Stability Condition to Avoid:HEAT,MOISTURE
Hazardous Decomposition Products:HYDROGEN CHLORIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF COLLECTED MATERIAL IN ACCORDANCE WITH
LOCAL,STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SULFURIC ACID, 9682
CAGE:DO803
CAGE:DO803
CAGE:70829
============= Composition/Information on Ingredients =============
Ingred Name:SULFURIC ACID (SARA 302/313) (CERCLA). LD50:(ORAL,RAT) 2140
MG/KG.
CAS:7664-93-9
RTECS #:WS5600000
Fraction by Wt: 80-98%
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3/3 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 2-20%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPDAT:CONSUMPTION) & INCLUDED SM NUMBERS OF SUBJECTS.
BASED ON OVERALL WT OF EVID FROM ALL HUMAN & CHRONIC (ING 4)
RTECS #:9999999ZZ
Ingred Name:ING 3:ANIMAL STUDIES, NO DEFINITIVE CASUAL RELATIONSHIP
BETWEEN SULFURIC ACID MIST EXPOSURE & RESPIRATORY TRACT (ING 5)
RTECS #:9999999ZZ
Ingred Name:ING 4:CANCER HAS BEEN SHOWN. TARGET ORGANS:RESPIRATORY
SYSTEM, LUNGS, EYES, SKIN, TEETH, KIDNEYS.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC:ON CLTHG. DO NOT BREATHE VAP. KEEP IN TIGHTLY
CLSD CNTNR. LOOSEN CLOSURE CAUTIOUSLY. USE W/ADEQ (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6:VENT. IN CASE OF SPILL NEUT W/SODA ASH OR LIME &
PLACE IN DRY CNTNR.
RTECS #:9999999ZZ
Ingred Name:EYE PROT:& FULL LENGTH FACESHIELD .
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENT 1
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHALATION:SEVERE IRRITATION OR
BURNS OF RESPIRATORY SYSTEM, PULMONARY EDEMA, LUNG INFLAMMATION.
SKIN & EYE CONT:SEVERE BURNS. INGESTION:NAUSEA, VOMITING, SEVERE
BURNS TO MOUTH, THROAT, & STOMAC H, KIDNEY DISFUNCTION.
CHRONIC:LUNG DAMAGE. THE IARC CLASSIFIED "STRONG INORG ACID MISTS
CONTAINING (EFTS OF OVEREXP)
Explanation of Carcinogenicity:SULFURIC ACID:IARC MONOGRAPHS ON EVAL OF
CARCIN RISK OF CHEMS TO MAN, VOL 54, PG 41, 1992:GROUP 1.
ANIMAL:PULM IRRIT.
Effects of Overexposure:HLTH HAZ:SULFURIC ACID" AS CATEGORY 1 CARCIN,
SUBSTANCE THAT IS "CARCINOGENIC TO HUMANS." THIS CLASSIFICATION IS
FOR INORG ACID MISTS ONLY & DOES NOT APPLY TO SULFURIC
ACID/SULFURIC ACID SOLNS. BASIS FOR IARC CLASSIFICATION RESTS ON
SEVERAL EPIDEMIOLOGY STUDIES WHICH HAVE SEVERAL DEFICIENCIES. THESE
STUDIES (SUPDAT)
Medical Cond Aggravated by Exposure:RESPIRATORY SYSTEM DISEASE.
======================= First Aid Measures =======================
First Aid:INGEST:CALL PHYS. IF SWALLOWED, DO NOT INDUCE VOMIT. IF
CONSCIOUS, GIVE LG AMTS OF WATER. INHAL:REMOVE TO FRESH AIR. IF NOT
BRTHG, GIVE ARTF RESP. IF BRTHG IS DFCLT, GIVE OXYG. PROMPT ACTION
IS ESSNTL . SKIN:IMMED FLUSH W/PLENTY OF WATER FOR @ LST 15 MINS
WHILE REMOVING CONTAMD CLTHG & SHOES. WASH CLTHG BEFORE RE-USE.
EYE:IMMED FLUSH W/PLENTY OF WATER FOR @ LEAST 15 MINUTES.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Extinguishing Media:USE DRY CHEMICAL OR CARBON DIOXIDE. DO NOT USE
WATER.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . DO NOT GET WATER INSIDE CONTAINERS.
Unusual Fire/Explosion Hazard:REACTS W/MOST METALS TO PRDCE HYDROGEN
GAS, WHICH CAN FORM EXPLO MIX W/AIR. VIOLENT EXOTHERMIC RXN OCCURS
W/WATER. SUFFICIENT HEAT MAY BE PRODUCED TO (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR NIOSH APPRVD SCBA & FULL PROT CLTHG. STOP
LEAK IF CAN BE DONE WITHOUT RISK. DO NOT USE WATER. NEUT SPILL
AND/OR WASHINGS WITH SODA ASH OR LIME. WITH CLEAN SHOVEL, PLACE
MATL INTO CLEAN, DRY CNTNR& COVER. MOVE CNTNR(S) FROM SPILL AREA.
Neutralizing Agent:MFR NEUTRASORB R OR TEAM R 'LOW NA+' ACID.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CNTNR TIGHTLY CLSD. STORE IN
CORR-PROOF AREA. KEEP CNTNRS OUT OF SUN & AWAY FROM HEAT. ISOLATE
FROM INCOMPATIBLE MATERIALS.
Other Precautions:NOTE:WHEN HNDLG LIQ PRODS, SECONDARY PROT CNTNRS MUST
BE USED FOR CARRYING. POISON! DANGER! CAUSES SEV BURNS. REACTS
VIOLENTLY W/WATER. HARMFUL IF SWALLOWED/INHALED. CONT W/OTHER MATLS
MAY CAUSE FIRE. DO NOT GET IN EYES, ON SKIN, (ING 6)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED WHERE ADEQUATE VENTILATION
CONDITIONS EXIST. IF AIRBORNE CONCENTRATION EXCEEDS TLV, A NIOSH
APPRVD SELF-CONTAINED BREATHING APPARATUS IS ADVISED.
Ventilation:USE GENERAL OR LOCAL EXHAUST VENTILATION TO MEET TLV
REQUIREMENTS.
Other Protective Equipment:UNIFORM, PROTECTIVE SUIT. ANSI APPRVD EYE
WASH & DELUGE SHOWER .
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
PH:1.0 (0.05M SOLUTION). EXPLO HAZ:IGNITE COMBUST MATLS. TOX GASES
PRDCED:SULFUR DIOXIDE, HYDROGEN. MATLS TO AVOID:SULFIDES, CYANIDES,
STRONG OXIDIZING AGENTS, CARBIDES. EFTS OF OVEREXP:DID NOT ACCOUN T
FOR EXPOS TO OTHER SUBSTANCES, SOME KNOWN TO BE ANIMAL/POTNTL HUMAN
CARCINS, SOCIAL INFLUENCES (SMKNG/ALCOHOL (ING 3)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:620F,327C
Melt/Freeze Pt:M.P/F.P Text:28.0F,-2.2C
Vapor Pres:<0.3
Vapor Density:3.4
Spec Gravity:1.84 (H*2O=1)
pH:SUPDAT
Evaporation Rate & Reference:<1 (BUTYL ACETATE =1)
Solubility in Water:COMPLETE (100%)
Appearance and Odor:CLEAR, COLORLESS TO YELLOW VISCOUS LIQUID.
ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER, MOST COMMON METALS, ORGANIC MATLS, STRONG REDUCING AGENTS,
COMBUST MATLS, STRONG BASES, CARBONATES, (SUPDAT)
Stability Condition to Avoid:MOISTURE, HEAT.
Hazardous Decomposition Products:OXIDES OF SULFUR, HYDROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE, AND LOCAL ENVIRONMENTAL REGULATIONS. EPA HAZARDOUS
WASTE NUMBER:D002, D003 (CORROSIVE, REACTIVE WASTE).
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PR-1593 PART B
Preparer's Name:RBW
CAGE:DO563
CAGE:83574
CAGE:DO563
============= Composition/Information on Ingredients =============
Ingred Name:N,N BIS(2-HYDROXYPROPYL)ANILINE.
CAS:3077-13-2
Fraction by Wt: 10%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRIT, WATERING & POSS
REVERSIBLE CORNEAL DMG. SKIN: LOCAL IRRIT & DISCOLORATION. MAY
CAUSE ALLERGIC SKIN RASH IN SENSITIZED INDIVIDUALS. INHAL: DUE TO
LOW VOLAT, SIGNIFICANT EXPOS TO VAPOR IS N OT EXPECTED UNLESS
OVERHEATED. EXCESS INHAL CAN PRDCE IRRIT OF NOSE, THROAT, & RESP
TRACT. EXCESS & (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: EXTENSIVE EXPOS CAN PRDCE REVERSIBLE
SYMPS OF BRONCHITIS. SENSITIZED INDIVIDUALS WILL DEVELOP
ASTHMA-LIKE SYMPS AT LOW EXPOS. INGEST: MAY RESULT IN IRRITATION &
SOME CORROSIVE ACTION IN THE MOUTH, STOMACH TISSUE & DIGESTIVE
TRACT.
Medical Cond Aggravated by Exposure:INDIVIDUALS SUFFERING FROM ASTHMA
OR OTHER CHRONIC RESP CONDITIONS MAY EXHIBIT A HEIGHTENED
SENSITIVITY TO ISOCYANATES & SHOULD AVOID INHALATION EXPOSURE.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH LUKE-WARM WATER FOR AT LEAST 15 MINUTES.
CONSULT MD. SKIN: WASH WITH SOAP & WATER FOR AT LEAST 15 MINS. IF
IRRIT PERSISTS, CONSULT MD. INHAL: REMOVE TO FRESH AIR. IF RESP
SYMPTOMS ARE PRESENT, CONSULT MD. INGEST: GIVE MILKOR WATER TO
DRINK. CONSULT MD.
===================== Fire Fighting Measures =====================
Flash Point:NOT FLAMMABLE
Extinguishing Media:FOAM, CO*2, DRY CHEMICAL, WATER SPRAY.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL PROT
EQUIP. USE WATER TO COOL HEAT EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:HIGH TEMPERATURES MAY CAUSE PRESSURE
BUILD-UP IN CLOSED CONTAINERS.
================== Accidental Release Measures ==================
Spill Release Procedures:COVER WITH ABSORBANT. SCOOP INTO CONTAINERS.
CLEAN-UP RESIDUE WITH 1,1,1-TRICHLOROETHANE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE.
Other Precautions:NONE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN.
Ventilation:GENERAL VENTILATION TO MAINTAIN VAPOR BELOW PEL.
Other Protective Equipment:EMERGENCY EYE BATH & DELUGE SHOWER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:1.05
Solubility in Water:SLIGHT
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER, AMINES, STRONG BASES, ALCOHOLS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:OXIDES OF CARBON & NITROGEN AND
POSSIBLE TRACES OF HCN.
==================== Disposal Considerations ====================
Waste Disposal Methods:NOT A HAZARDOUS WASTE ACCORDING TO EPA
REGULATIONS. CONSULT LOCAL, STATE & FEDERAL REGULATIONS PRIOR TO
DISPOSAL OF SPILLAGE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:REGULAR UNLEADED GAS, CPS201152
CAGE:81230
CAGE:81230
CAGE:04BH0
============= Composition/Information on Ingredients =============
Ingred Name:BENZENE (SARA 313) (CERCLA)
CAS:71-43-2
RTECS #:CY1400000
Fraction by Wt: <4.2%
OSHA PEL:N/K
ACGIH TLV:10 PPM
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:BENZENE, ETHYL-; (ETHYL BENZENE) (SARA 313)
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: >1%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM;125 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:XYLENE (SARA 313) (CERCLA)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: >1%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM;150 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:TOLUENE (SARA 313) (CERCLA)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: >1%
OSHA PEL:200 PPM
ACGIH TLV:50 PPM, S
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:HEXANE; (N-HEXANE) (CERCLA)
CAS:110-54-3
RTECS #:MN9275000
Fraction by Wt: >1%
OSHA PEL:500 PPM
ACGIH TLV:50 PPM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:BUTANE; (N-BUTANE)
CAS:106-97-8
RTECS #:EJ4200000
Fraction by Wt: >1%
OSHA PEL:800 PPM
ACGIH TLV:800 PPM
Ingred Name:PENTANE; (N-PENTANE)
CAS:109-66-0
RTECS #:RZ9450000
Fraction by Wt: >1%
OSHA PEL:1000 PPM
ACGIH TLV:600 PPM;750 STEL
Ingred Name:HEPTANE; (N-HEPTANE)
CAS:142-82-5
RTECS #:MI7700000
Fraction by Wt: >1%
OSHA PEL:500 PPM
ACGIH TLV:400 PPM;500 STEL
Ingred Name:CYCLOHEXANE, METHYL-; (METHYLCYCLOHEXANE)
CAS:108-87-2
RTECS #:GV6125000
Fraction by Wt: >1%
OSHA PEL:500 PPM
ACGIH TLV:400 PPM
Ingred Name:BENZENE, TRIMETHYL-(MIXED ISOMERS); (TRIMETHYLBENZENE)
CAS:25551-13-7
RTECS #:DC3220000
Fraction by Wt: >1%
OSHA PEL:25 PPM
ACGIH TLV:25 PPM
Ingred Name:PENTANE, 2,2,4-TRIMETHYL-; (2,2,4-TRIMETHYLPENTANE)
(CERCLA)
CAS:540-81-1
RTECS #:SA3320000
Fraction by Wt: >1%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ETHER, TERT-BUTYL METHYL-; (METHYL TERT-BUTYL ETHER) (MTBE)
(SARA 313) (CERCLA)
CAS:1634-04-4
RTECS #:KN5250000
Fraction by Wt: <15%
Other REC Limits:50 PPM STEL (MFR)
OSHA PEL:N/K
ACGIH TLV:40 PPM (MFR)
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:ETHER, TERT-BUTYL ETHYL; (ETHYL TERT BUTYL ETHER (ETBE))
CAS:637-92-3
RTECS #:KN4730000
Fraction by Wt: <18%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:BUTANE, 2-METHOXY-2-METHYL-; (TERT-AMYL METHYL ETHER
(TAME))
CAS:994-05-8
RTECS #:EK4421000
Fraction by Wt: <17%
Other REC Limits:50 PPM STEL (MFR)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ETHYL ALCOHOL; (ETHANOL)
CAS:64-17-5
RTECS #:KQ6300000
Fraction by Wt: <10%
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM
Ingred Name:EFTS OF OVEREXP:SYS. >1000 PPM MAY CAUSE CNS EFTS SUCH AS
HDCH, DIZZ, LOSS OF APPETITE, WEAK & LOSS OF COORD. (ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16:>5000 PPM MAY CAUSE LOSS OF CONSCIOUSNESS, COMA &
DEATH. INTENTIONAL EXPOS TO HIGH CONCS HAVE BEEN (ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17:REPORTED TO RSLT IN CONVLS, DELIRIUM &
HALLUCINATIONS. SIGNS & SYMPS:EYE:PAIN, TEARS, SWELL, REDNESS &
(ING 19)
RTECS #:9999999ZZ
Ingred Name:ING 18:BLURRED VISION. SKIN:PAIN/FEELING OF HEAT,
DISCOLORATION, SWELL, BLISTERING. INHAL:RESP TRACT IRRIT. (ING 20)
RTECS #:9999999ZZ
Ingred Name:ING 19:INGEST:HDCH, DIZZ, LOSS OF APPETITE, WEAK & LOSS OF
COORD. NOTE:TOLUENE APPEARS ON NAVY LIST OF OCCUP (ING 21)
RTECS #:9999999ZZ
Ingred Name:ING 22:CHEM REPRO HAZS. SEEK CONSULTATION FROM APPROP HLTH
PROFESSIONALS CONCERNING LATEST HAZ LIST INFO & SAFE (ING 22)
RTECS #:9999999ZZ
Ingred Name:ING 21:HNDLG & EXPOS INFO . FOR MORE HLTH HAZ INFO &
TOXICOLOGICAL INFO, CONTACT NEHC .
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC:PERS. IF MED ADVICE CANNOT BE OBTAINED, TAKE
PERS & PROD CNTNR TO NEAREST MED EMER TREATMENT (ING 24)
RTECS #:9999999ZZ
Ingred Name:ING 23:CENTER/HOSPITAL. INHAL:MOVE PERS TO FRESH AIR. IF
EFTS CONTINUE, SEE MD. NOTE TO MD:INGEST OF THIS PROD/ (ING 25)
RTECS #:9999999ZZ
Ingred Name:ING 24:SUBSEQUENT VOMITING CAN RESULT IN ASPIRATION OF
LIGHT HYDROCARBON LIQUID WHICH CAN CAUSE PNEUMONITIS.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(ORAL,RAT) >5 ML/KG.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:EYE:SLIGHTLY IRRIT & COULD CAUSE PRLNG
(DAYS) IMPAIRMENT OF VISION. CONT W/VAPS, FUMES/SPRAY MIST COULD
ALSO CAUSE SIMILAR SIGNS & SYMPS. SKIN:MOD IRRIT. CONT COULD CAUSE
PRLNG (DAYS) INJURY TO AFFECT ED AREA. IF ABSORBED, CONSIDERED
PRACTICALLY NON-TOX. PRLNG/FREQUENTLY RPTD CONT MAY CAUSE SKIN TO
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:BENZENE:IARC MONOGRAPHS, SUPP, VOL 7, PG
120, 1987:GRP 1. NTP 7TH ANNUAL REPORT ON CARCINS, 1994:KNOWN TO BE
(SUPP DATA)
Effects of Overexposure:HLTH HAZ:BECOME CRACKED/DRY FROM DEFAT ACTION.
INGEST:SLIGHTLY TOX. TARGET ORG(S) IS NERV SYS. BECAUSE OF LOW
VISCOSITY OF SUBSTANCE, IT CAN DIRECTLY ENTER LUNGS IF SWALLOWED
(ASPIR). ONCE IN LUNGS, S UBSTANCE VERY DFCLT TO REMOVE & CAN CAUSE
SEV INJURY TO LUNGS & DEATH. INHAL:SLIGHTLY TOX. TARGET ORG(S) IS
NERV(ING 16)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH IMMED W/FRESH WATER FOR AT LST 15 MINS WHILE
HOLDING LIDS OPEN. REMOVE CONT LENSES. IF IRRIT PERSISTS, SEE MD.
SKIN:REMOVE CONTAM CLTHG. WASH SKIN THORO W/SOAP & WATER. SEE MD IF
ANY SIGNS/ SYMPS OCCUR. DISCARD CONTAM NON-WATERPROOF SHOES &
BOOTS. WASH CONTAM CLTHG. INGEST:GIVE WATER/MILK TO DRINK &
DO SO BY MED (ING 23)
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:<-49F,<-45C
Lower Limits:1.4%
Upper Limits:7.6%
Extinguishing Media:FIRE FIGHTING FOAM: ALCOHOL RESISTANT TYPE (AR);
AFFF; CO*2; DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:EXTREME FIRE HAZ. LIQ VERY QUICKLY EVAPS,
EVEN AT LOW TEMPS & FORMS VAP WHICH CAN CATCH FIRE & BURN W/EXPLO
VIOLENCE. INVISIBLE VAP SPREADS EASILY & CAN(SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:ELIM ALL SOURCES OF IGNIT IN VICIN. CLEAN UP
SPILLS IMMED, OBSERVING PRECS. CLEAN UP SM SPILLS USING APPROP
TECHNIQUES SUCH AS SORBENT MATLS/PUMPING. WHERE FEASIBLE & APPROP,
REMOVE CONTAM SOIL. FOLLO W PRESCRIBED PROCS FOR REPORTING & (SUPP
DATA)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NEVER SIPHON GAS BY MOUTH. USE ONLY AS
MOTOR FUEL. DO NOT USE FOR CLEANING, PRESS APPLIANCE FUEL/ANY OTHER
SUCH USE. READ & OBSERVE ALL PRECS ON LBL.
Other Precautions:DO NOT USE/STORE NEAR FLAME, SPKS/HOT SURFS. KEEP
CNTNR CLSD. DO NOT TRANSFER LIQ TO UNLABELED CNTNR. DO NOT WELD,
HEAT/DRILL CNTNR. REPLACE CAP/BUNG. EMPTIED CNTNR STILL CNTNS
HAZ/EXPLO VAP/LIQ. KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NO SPECIAL RESP PROT IS NORMALLY REQD. HOWEVER,
IF OPERATING CNDTNS CREATE AIRBORNE CONCS WHICH EXCEED REC EXPOS
STDS, USE OF A NIOSH APPRVD RESP IS REQD. REFER TO OSHA BENZENE STD
TO DETERM WHAT TYPE OF RESP IS REQD BASED ON EXPOS LEVELS.
Ventilation:USE ONLY IN WELL VENTILATED AREAS.
Other Protective Equipment:ANSI APPROVED EYE WASH FOUNTAIN & DELUGE
SHOWER . SKIN CONTACT CAN BE MINIMIZED BY PROTECTIVE CLOTHING.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
VP:5-15 PSI @ 100F. EXPLAN OF CARCIN:CARCIN. OSHA REGULATED:29 CFR
1910.1028. HUMAN:MYELOID LEUKEMIA, HODGKINS DISEASE, LYMPHOMA.
EXPLO HAZ:BE SET ON FIRE BY MANY SOURCES SUCH AS PILOT LIGHTS,
WELDING EQUIP & ELEC MOTORS & SWITCHES. SPILL PROC:RESPONDING TO
LGR RELS. FOR INFO ON SPILL REPORTING PROCS CONT NEHC .
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>77F,>25C
Vapor Pres:SUPP DATA
Vapor Density:3-4
Spec Gravity:0.7-0.8
Solubility in Water:INSOLUBLE
Appearance and Odor:ORANGE TO BROWN LIQUID.
Percent Volatiles by Volume:>99
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MAY REACT W/STRONG OXIDIZING AGENTS, SUCH AS CHLORATES, NITRATES,
PEROXIDES, ETC.
Stability Condition to Avoid:NO DATA AVAILABLE.
Hazardous Decomposition Products:NORMAL COMBUSTION FORMS CARBON DIOXIDE
& WATER VAPOR; INCOMPLETE COMBUSTION CAN PRODUCE CARBON MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS . FOR COMPLETE INFORMATION ON WASTE DISPOSAL &
ECOLOGICAL INFORMATION, CONTACT NEHC .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:3728 SODIUM HYDROXIDE PELLETS
CAGE:DO803
CAGE:DO803
CAGE:70829
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM HYDROXIDE, CAUSTIC SODA, LYE
CAS:1310-73-2
RTECS #:WB4900000
Fraction by Wt: 40%
Other REC Limits:2MG/M3 CEILING NIOSH
OSHA PEL:2 MG/CUM
ACGIH TLV:2 MG/CUM CEILING
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: HARMFUL, SEVERE
IRRITATION/BURNS OF RESPIRATORY SYSTEM, PULMONARY EDEMA, LUNG
INFLAMMATION MAY CAUSE RESPIRATORY SYSTEM DAMAGE. SKIN: SEVERE
IRRITATION/BURNS. EYES: SEVERE IRRITATION/BURNS , PERMANENT CORNEAL
DAMAGE. INGESTION: HARMFUL/FATAL, SEVERE BURNS TO MOUTH, THROAT &
STOMACH.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, BURNS, NAUSEA, VOMITING.
Medical Cond Aggravated by Exposure:DAMAGED SKIN.
======================= First Aid Measures =======================
First Aid:INGESTION: DON'T INDUCE VOMITING. IF CONSCIOUS, GIVE LARGE
AMOUNTS OF WATER. FOLLOW W/DILUTED VINEGAR, FRUIT JUICE/WHITES OF
EGGS BEATEN W/WATER. INHALATION: REMOVE TO FRESH AIR. GIVE
CPR/OXYGEN IF NE EDED. PROMPT ACTION IS ESSENTIAL. SKIN/EYES:
IMMEDIATELY FLUSH W/PLENTY OF WATER FOR 15 MINS. OBTAIN MEDICAL
ATTENTION IN ALL CASES. (SEE SUPP)
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Extinguishing Media:USE EXTINGUISHING MEDIA APPROPRIATE FOR SURROUNDING
FIRE.
Fire Fighting Procedures:WEAR PROPER PROTECTIVE EQUIPMENT & SCBA W/FULL
FACEPIECE OPERATED IN POSITIVE PRESSURE MODE. FLOOD W/WATER SPRAY
TO PREVENT SPLASHING OF MATERIAL.
Unusual Fire/Explosion Hazard:CONTACT W/MOISTURE/WATER MAY GENERATE
HEAT TO IGNITE COMBUSTIBLE MATERIALS. REACTS W/MOST METALS TO
PRODUCE HYDROGEN GAS WHICH FORM EXPLOSIVE MIXTURE W/AIR.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR SCBA & FULL PROTECTIVE CLOTHING. W/CLEAN
SHOVEL, CAREFULLY PLACE MATERIAL INTO CLEAN, DRY CONTAINER & COVER;
REMOVE FROM AREA. FLUSH AREA W/WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED. STORE
IN CORROSION-PROOF AREA. STORE IN A DRY AREA. ISOLATE FROM
INCOMPATIBLE MATERIALS. USE W/ADEQUATE VENTILATION.
Other Precautions:WHEN HANDLING LIQUID PRODUCTS, SECONDARY PROTECTIVE
CONTAINERS MUST BE USED FOR CARRYING. DON'T GET IN EYES,
SKIN/CLOTHING. AVOID SPATTERING BY SLOWLY ADDING TO SOLUTION. AVOID
BREATHING DUST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF AIRBORNE CONCENTRATION EXCEEDS TLV AT 100
PPM, A HIGH EFFICIENCY PARTICULATE RESPIRATOR IS RECOMMENDED. ABOVE
THIS LEVEL, A SCBA IS ADVISED.
Ventilation:GENERAL/LOCAL EXHAUST TO MEET TLV REQUIREMENTS.
Other Protective Equipment:APRON, UNIFORM, LAB COAT, LABORATORY
PROTECTIVE EQUIPMENT.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:2534F
Melt/Freeze Pt:M.P/F.P Text:604F
Vapor Pres:<1
Spec Gravity:2.13
pH:14
Solubility in Water:APPRECIABLE
Appearance and Odor:WHITE PELLETS/FLAKES, ODORLESS
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER/STRONG ACIDS/MOST METALS/COMBUSTIBLE MATERIALS/ORGANIC
MATERIALS/ZINC/ALUMINUM/PEROXIDES/HALOGENATED HYDROCARBONS.
Stability Condition to Avoid:MOISTURE
Hazardous Decomposition Products:REACTS VIOLENTLY W/WATER & ACIDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS. EPA HAZARDOUS WASTE NUMBER: D002, D003 CORROSIVE,
REACTIVE WASTE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SUPERKOTE COMMERCIAL LATEX BLOCK FILLER, 94
CAGE:33200
CAGE:33200
============= Composition/Information on Ingredients =============
Ingred Name:PIGMENTS
Fraction by Wt: 64.0%
Ingred Name:VEHICLE
Fraction by Wt: 8.9%
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 25.7%
Ingred Name:ETHYLENE GLYCOL
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: 1.4%
OSHA PEL:50 PPM, C
ACGIH TLV:50 PPM, C VAPOR
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NONE
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL: INDUCE VOMITING, CALL A PHYSICIAN. EYES: RINSE WITH
WATER FOR AT LEAST 15 MIN. SKIN: FLUSH WITH COPIOUS AMOUNTS OF
WATER. CALL MD . INGEST: GET MD IMMED .
===================== Fire Fighting Measures =====================
Extinguishing Media:USE EXTINGUISHING MEDIA APPROPRIATE FOR SURROUNDING
FIRE .
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH AWAY WITH WATER OR ABSORB ON APPROPRIATE
ABSORBANT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP FROM FREEZING.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL EXHAUST ONLY TO AVOID EXCESSIVE INHALATION WHEN
SPRAYING.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
VAPOR PRESSURE: SAME AS WATER.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:SUPP DATA
Vapor Density:> 1
Spec Gravity:1.722
Evaporation Rate & Reference:1 (WATER=1)
Solubility in Water:INMFINITE
Appearance and Odor:THICK, WHITE OPAQUE LIQUID; MILD SLIGHTLY SWEET
ODOR.
Percent Volatiles by Volume:46.7
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:FREEZING TEMPERATURES.
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:AMMONIUM NITRATE
CAGE:1B464
CAGE:1B464
============= Composition/Information on Ingredients =============
Ingred Name:AMMONIUM NITRATE
CAS:6484-52-2
RTECS #:BR9050000
Fraction by Wt: 100%
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT): 2217 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION:RESPIRATORY IRRITATION,
METHEMOGLOBINEMIA, PULMONARY EDEMA & CHEMICAL PNEUMONITIS.
SKIN:IRRITATION, BURNS & DERMATITIS. EYES:IRRITATION, BURNS &
CONJUNCTIVITIS. INGESTION:MILD G/I IRRITATIO N, ABDOMSYSTEMIC
ACIDOSIS & METHEMOGLOBINEMIA W/CYANOSIS, ANEMIA, NEPHRITIS.
MODERATELY TOXIC.
Explanation of Carcinogenicity:MANUFACTURER GAVE NO INFORMATION ABOUT
CARCINOGENICITY. HMIS FOUND NO LISTING & DOES NOT EXPECT IT TO BE
CARCINOGENIC.
Effects of Overexposure:INHALATION:SORE THROAT, COUGHING, DIFFICULT
BREATHING, SEVERE LUNG CONGESTION, ACIDOSIS, METHEMOGLOBINEMIA.
SKIN/EYES:IRRITATION, REDNESS, PAIN, BURNS. INGESTION:G/I
IRRITATION, ABDOMINAL SPASMS, NAU SEA, FAINTNESS, ANEMIA,
NEPHRITIS. POISONING MAY AFFECT THE BLOOD.
Medical Cond Aggravated by Exposure:MFR GAVE NO INFORMATION ON MSDS.
======================= First Aid Measures =======================
First Aid:IF ANY IRRITATION PERSISTS OR SEVERE, GET MEDICAL ATTENTION.
EYE:FLUSH W/WATER FOR 15 MIN. SKIN:WASH W/SOAP & WATER. REMOVE
CONTAMINATED CLOTHING & LAUNDER BEFORE REUSE. INHALED:REMOVE FROM
CONTAMINAT ED AREA. AID OR RESTORE BREATHING AS NEEDED.
INGESTED:GIVE LARGE AMOUNTS OF MILK OR WATER TO DRINK AND INDUCE
VOMITING. GET IMMEDIATE MEDICAL ATTENTION. SEE DRIESBACH HADBOOK OF
POISONING FOR ANTIDOTE
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER ONLY. NO DRY CHEMICAL, CO2 OR HALON.
Fire Fighting Procedures:DO NOT MOVE CARGO/VEHICLE AFTER EXPOSURE TO
HEAT. APPLY COOLING WATER TO SIDES OF CONTAINERS FLAMES UNTIL WELL
AFTER FIRE IS OUT.
Unusual Fire/Explosion Hazard:USE UNMANNED HOSE HOLDER OR MONITOR
NOZZLES OR WITHDRAW FROM AREA & LET FIRE BURN. ISOLATE FOR 0.5 MILE
FROM TANK, RAIL CAR ETC. FLOOD W/WATER OR EVACUATE.
================== Accidental Release Measures ==================
Spill Release Procedures:KEEP COMBUSTIBLES AWAY FROM SPILLED MATERIAL.
DO NOT TOUCH SPILL. STOP LEAK IF W/O RISK. USE WATER SPRAY TO
REDUCE VAPORS. TAKE UP ABSORBENT MATERIAL & PLACE INTO CONTAINERS
FOR DISPOSAL. DIKE LARGE S PILL FOR LATER DISPOSAL. ISOLATE AREA.
DENY ENTRY.
Neutralizing Agent:MFR GAVE NO INFORMATION ON MSDS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE & DISPOSE I/A/W ALL FEDERAL,
STATE & LOCAL REGULATIONS. PROTECT CONTAINERS FROM DAMAGE. STORE IN
WELL VENTILATED NIRE RESESTANT BUILDINGS.
Other Precautions:EQUIP STORAGE AREA W/AUTOMATIC SPRINKLERS. PLUG FLOOR
DRAINS & RECESSES TO PREVENT ENTRAPMENT OF FLOWING MOLTEN NITRATE
DURING FIRE. SEPARATE FROM ORGANIC MATERIALS. CONSULT NFPA 490 FOR
APPLICABLE ST ROAGE REQUIREMENTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SELECTION OF RESPIRATOR MUST BE BASED ON LEVELS
OF CONTAMINATION FOUND IN THE WORKPLACE. DO NOT EXCEED WORKING
LIMITS OF RESPIRATO. RESPIRATOR MUST BE JOINTLY APPROVED BY NIOSH &
MSHA.
Ventilation:PROVIDE LOCAL EXHAUST. EQUIPMENT MUST BE EXPLOSION PROOF IF
EXPLOSIVE CONCENTRATIONS OF DUST, VAPOR OR FUME ARE PRESENT.
Other Protective Equipment:EYE WASH FOUNTAIN IN IMMEDIATE WORK AREA IF
ANY POSSIBILITY OF EXPOSURE OF EMPOLOYEES EYES.
Work Hygienic Practices:MFR:?.HMIS:USE GOOD CHEMICAL HYGIENE
PRACTICES. AVOID CONTACT IF AT ALL POSSIBLE. WASH THOROUGHLY AFTER
HANDLING.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:D1
NRC/State Lic Num:NONE
Boiling Pt:B.P. Text:410F/210C
Melt/Freeze Pt:M.P/F.P Text:338F/170C
Spec Gravity:1.725
Solubility in Water:118%
Appearance and Odor:COLORLESS TO WHITE, DELIQUESCENT, RHOMBIC CRYSTALS
OR GRANULES, ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:NO
STRONG ALKALIES, ACIDS, METALS (POWDERED/SALTS), ORANIC MATERIALS,
REDUCING AGENTS, SODIUM, ACETIC ACID, POTASSIUM
Stability Condition to Avoid:HEAT,FLAME,SHOCK. CAPEABLE OF DETONATING
IF HEATED OR SUBJECTED TO SHOCK. EASILY OXIDIZED MATERIAL INCREASES
SENSTIVITY.
Hazardous Decomposition Products:TOXIC & CORROSIVE FUMES OF AMMONIA &
TOXIC OXIDES OF NITROGEN
Conditions to Avoid Polymerization:HAZARDOUS POLYMERIZATION HAS NOT
BEEN REPORTED TO OCCUR UNDER NORMAL TEMPERATURES OR PRESSURES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF I/A/W STANDARDS APPLICABLE TO
GENERATORS OF HAZARDOUS WASTE. EPA HAZARDOUS WASTE NUMBERS. D001 &
D003. 100 POUND CERCLA SECTION 103 REPORTABLE QUANTITY.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PHOTO CONDUCTOR, DKCN-432ASC03
CAGE:S4117
CAGE:S4117
============= Composition/Information on Ingredients =============
Ingred Name:ALUMINIUM CYLINDER
Fraction by Wt: >97%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:BINDER RESIN
Fraction by Wt: <1%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PHOTOSENSITIVE MATERIAL
Fraction by Wt: <1%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PIGMENT
Fraction by Wt: <1%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ALL COMPONENTS OF PHOTOCONDUCTIVE
COATING HAVE BEEN SUBJECTED TO THE "AMES TEST", AND SHOWN TO HAVE
NO HARMFUL EFFECT. (TEST NEGATIVE).
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:NONE.
Medical Cond Aggravated by Exposure:NONE.
======================= First Aid Measures =======================
First Aid:NONE TREATMENT IS REQUIRED. INGEST: CALL MD IMMEDIATELY .
INHAL: REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTF RESP)
. EYES: IMMEDIATELY FLUSH W/POTABLE WATER FOR A MINIMUM OF 15 M
INUTES, SEEK ASSISTANCE FROM MD .SKIN: FLUSH W/COPIOUS AMOUNTS OF
WATER. CALL MD .
===================== Fire Fighting Measures =====================
Extinguishing Media:CO*2, DRY CHEMICAL, FOAM AND WATER.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:THIS MATERIAL HAS NO UNUSUAL FIRE OR
EXPLOSION HAZARDS.
================== Accidental Release Measures ==================
Spill Release Procedures:NOT APPLICABLE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED UNDER NORMAL USE. NIOSH APPROVED
RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:NOT REQUIRED.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Spec Gravity:2.7
Solubility in Water:NEGLIGIBLE
Appearance and Odor:GREEN CYLINDER; ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CO AND NO*X.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE MATERIAL MAY BE DUMPED UNDER CONDITIONS
WHICH MEET AT FEDERAL, STATE AND LOCAL ENVIRONMENTAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ALUMINUM ALLOYS 6000
CAGE:1JS97
CAGE:1JS97
============= Composition/Information on Ingredients =============
Ingred Name:SUPDAT:FORMS EXPLO MIXTS IN AIR. IT ALSO WILL FORM EXPLO
MIXTS IN AIR IN PRESENCE OF BROMATES, IODATES/AMMONIUM (ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15:NITRATE. STRONG OXIDIZERS CAUSE VIOLENT RXNS
W/CONSIDERABLE HEAT GENERATION.
RTECS #:9999999ZZ
Ingred Name:EFTS OF OVEREXP:INFRARED RADIATION & ULTRAVIOLET RADIA.
NOTE:LEAD (7439-92-1) APPEARS ON NAVY LIST OF OCCUP (ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17:REPRO HAZS. SEEK CONSULTATION FROM APPROP HLTH PROFS
CONCERNING LATEST HAZ LIST INFO & SAFE HNDLG & EXPOS(ING 19)
RTECS #:9999999ZZ
Ingred Name:ING 18:RECOMMENDATIONS .
RTECS #:9999999ZZ
Ingred Name:ALUMINUM (BASE METAL) (SARA III)
CAS:7429-90-5
RTECS #:BD0330000
Fraction by Wt: 90-99.7%
OSHA PEL:15 MG/M3 DUST;5 FUME
ACGIH TLV:10 MG/M3 DUST;5 RESP
Ingred Name:ALLOYING ELEMENTS (CONSISTING OF INGREDIENTS 3 - 14)
RTECS #:9999999ZZ
Ingred Name:CHROMIUM (SARA III). %:<0.01-0.4.
CAS:7440-47-3
RTECS #:GB4200000
Fraction by Wt: SEE ING
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:COPPER (SARA III)
CAS:7440-50-8
RTECS #:GL5325000
Fraction by Wt: <0.05-6%
OSHA PEL:0.1MG/M3 FUME;1 DUST
ACGIH TLV:0.2MG/M3 FUME;1 DUST
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:IRON (III) OXIDE; (IRON)
CAS:1309-37-1
RTECS #:NO7400000
Fraction by Wt: <0.35-1%
OSHA PEL:10 MG/M3 (FE)
ACGIH TLV:5 MG/M3(FE),B2; 9293
Ingred Name:MAGNESIUM OXIDE; (MAGNESIUM). %:<0.03-4.9.
CAS:1309-48-4
RTECS #:OM3850000
Fraction by Wt: SEE ING
OSHA PEL:15 MG/M3 PARTICULATE
ACGIH TLV:10 MG/M3;TDUST; 9293
Ingred Name:MANGANESE (SARA III). %:<0.02-1.5.
CAS:7439-96-5
RTECS #:OO9275000
Fraction by Wt: SEE ING
Other REC Limits:1 MG/M3;3 STEL(FUME)
OSHA PEL:(C) 5 MG/M3 DUST
ACGIH TLV:5 MG/M3 DUST 9293
Ingred Name:SILICON. %:<0.25-1.2.
CAS:7440-21-3
RTECS #:VW0400000
Fraction by Wt: SEE ING
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:TITANIUM. %:0.02-0.2. (LIMITS AS TIO*X)
CAS:7440-32-6
RTECS #:XR1700000
Fraction by Wt: SEE ING
Other REC Limits:15 MG/M3 (MFR)
OSHA PEL:10 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:ZINC OXIDE; (ZINC). %:<0.05-6.1.
CAS:1314-13-2
RTECS #:ZH4810000
Fraction by Wt: SEE ING
Other REC Limits:5MG/M3;10 STEL(FUME)
OSHA PEL:15MG/M3 TDUST/5 FUME
ACGIH TLV:10MG/M3 TDUST; 9293
Ingred Name:BISMUTH. %:<0.4-0.7.
CAS:7440-69-9
RTECS #:EB2600000
Fraction by Wt: SEE ING
Ingred Name:BORON
CAS:7440-42-8
RTECS #:ED7350000
Fraction by Wt: 0.06%MAX
Other REC Limits:15 MG/M3 OXIDE (MFR)
OSHA PEL:10 MG/M3 (AS OXIDE)
ACGIH TLV:10 MG/M3 (AS OXIDE)
Ingred Name:LEAD (SARA III). %:<0.4-0.7.
CAS:7439-92-1
RTECS #:OF7525000
Fraction by Wt: SEE ING
OSHA PEL:0.05 MG/M3
ACGIH TLV:0.15 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:VANADIUM (SARA III) (LIMITS AS V*2O*5)
CAS:7440-62-2
RTECS #:YW1355000
Fraction by Wt: 0.05%MAX
Other REC Limits:0.1 MG/M3,C(FUME)MFR
OSHA PEL:C,0.5 MG V2O5/M3 RD
ACGIH TLV:0.05 MG V205/M3;9293
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:FOR STD OPERATIONS (E.G., MELTING,
CUTTING, GRINDING), ALUMINUM ALLOYS PRESENT LOW HTLH RISK BY INHAL
& ARE USUALLY CONSIDERED NUISANCE DUST. TOX BY INGEST - NONE
EXPECTED. SKIN & EYES - NOT IRRIT. CH ROMIUM IS ALLOYING ELEMENT
CONSIDERED HAZ AS FUME; HOWEVER IT DOES NOT PRESENT CARCIN/OTHER
HLTH (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:CONCERNS DUE TO LOW CONC OF CHEM FORM
IN WHICH IT IS PRESENT. OVEREXP TO LEAD FUMES OVER EXTENDED PERIOD
OF TIME CAN RSLT IN SUCH TOX EFTS AS CNS DISTURBS, RENAL CHANGES,
PERIPHERAL NEUROPATH Y, GI DISTURBS, ANEMIA & CHROMOSOMAL CHANGES.
WELDING OF ALUMINUM ALLOYS MAY GEN CO, CO2 OZONE NITROGEN
OXIDES,(ING 17)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR; IF CONDITION CONTINUES, CALL MD.
EYE:FLUSH THOROUGHLY W/RUNNING WATER FOR AT LEAST 15 MINUTES TO
REMOVE PARTICULATE; GET MD. SKIN:REMOVE PARTICLES BY WASHING
THOROUGHLY W/SO AP & WATER. SEE MD IF CONDITION PERSISTS. INGEST:IF
SIGNIFICANT AMOUNTS OF METAL ARE INGESTED, SEE MD.
===================== Fire Fighting Measures =====================
Extinguishing Media:ALUMINUM ROD & TUBULAR PRODS:USE FIRE-FIGHTING
METHS & MATLS THAT ARE APPROP FOR SURROUND FIRE. SM CHIPS, FINE
(SUPDAT)
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . SM CHIPS, FINE TURNINGS & DUST:DO NOT USE
WATER OR HALOGEN AGENTS.
Unusual Fire/Explosion Hazard:AL ROD & TUBULAR PRODUCTS DO NOT PRESENT
FIRE/EXPLO HAZS UNDER NORM CNDTNS. SMALL CHIPS, FINE TURNINGS &
DUST MAY IGNITE READILY. DAMP ALUMINUM DUST (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:FINE TURNINGS & SMALL CHIPS SHOULD BE SWEPT UP
OR VACUUMED. SCRAP METAL CAN BE RECLAIMED FOR REUSE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT TOUCH CAST ALUMINUM
METAL/HEATED ALUMINUM PROD W/OUT KNOWING METAL TEMP. ALUMINUM
EXPERS NO COLOR CHANGE DURING HEATING. BURNS COULD RESULT.
Other Precautions:ALUMINUM POWDER MUST BE PACKAGED & SHIPPED AS
FLAMMABLE SOLID. MINIMIZE & CONTROL OPERATIONS PRODUCING DUST &
FUME.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE APPROPRIATE NIOSH/MSHA APPROVED RESPIRATOR
DEPENDING UPON POTENTIAL AIRBORNE CONTAMINANTS & THEIR
CONCENTRATIONS OR IF EXPOSURE LIMITS ARE REACHED OR EXCEEDED.
Ventilation:ADEQUATE VENTILATION.
Other Protective Equipment:AS NEEDED DEPENDING ON OPERATION & SAFETY
CODES.
Work Hygienic Practices:GOOD HOUSEKEEPING.
Supplemental Safety and Health
EXTING MEDIA:FINE TURNINGS & DUST:USE DRY PWDR/SAND EXTING MEDIA. DO
NOT USE H2O/HALOGEN. EXPLO HAZ:MAY SPONT HEAT W/LIBERATION OF
HYDROGEN TO FORM EXPLO AIR MIXTS. MOLTEN AL MAY EXPLODE ON CONT
W/H2O OR CERTAIN METAL OXIDES. MATLS TO AVOID:MIXTS OF HYDROGEN.
FINELY DIVIDED AL, SUCH AS SM CHIPS & FINES, WILL (ING 15)
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:>900F,>482C
Spec Gravity:2.5-2.9(H2O=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:SILVERY GRAY ODORLESS METAL; SOLID UNDER NORMAL
CONDITIONS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
REACTS W/STRONG ACIDS TO FORM HYDROGEN GAS. HALOGEN ACIDS & SODIUM
HYDROXIDE IN CONT W/ALUMINUM MAY GEN EXPLO (SUPDAT)
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:USED OR UNUSED PRODUCT SHOULD BE DISPOSED OF
I/A/W FEDERAL, STATE OR LOCAL LAWS & REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PATTERN ADHESIVE
CAGE:BOCAD
CAGE:BOCAD
============= Composition/Information on Ingredients =============
Ingred Name:ETHYL ACETATE (SARA III)
CAS:141-78-6
RTECS #:AH5425000
Fraction by Wt: 33%
Other REC Limits:400 PPM
OSHA PEL:400 PPM
ACGIH TLV:400 PPM; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ROSIN
Fraction by Wt: 31%
Ingred Name:ACRYLIC RESIN
Fraction by Wt: 36%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN: IRRITATION. INHALATION:
HEADACHE OR NAUSEA.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES/SKIN: IRRITATION. INHALATION: HEADACHE OR
NAUSEA.
======================= First Aid Measures =======================
First Aid:EYES/SKIN: FLUSH WELL W/WATER. INHALATION: MOVE TO FRESH AIR
& CALL PHYSICIAN. INGESTION: INDUCE VOMITING & CALL PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:24F
Lower Limits:2.5%
Upper Limits:11.5%
Extinguishing Media:CO2, FOAM
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL SOURCES OF IGNITION. FLUSH SMALL
SPILLS W/LARGE QUANTITIES OF WATER. LARGE SPILLS SHOULD BE
COLLECTED FOR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL AREA.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AIR SUPPLIED MASKS FOR VAPORS >2% VOLUME.
Ventilation:LOCAL EXHAUST: PREFERABLE. MECHANICAL: ACCEPTABLE.
Other Protective Equipment:EYE BATH
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:75C
Vapor Pres:69
Vapor Density:3.04
Spec Gravity:0.884
Evaporation Rate & Reference:(BU AC = 1): 6.15
Solubility in Water:22
Appearance and Odor:AMBER WATERY FLUID-FRUITY ODOR.
Percent Volatiles by Volume:36%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ALKALIS
Stability Condition to Avoid:HEAT, SPARKS & OPEN FLAMES.
Hazardous Decomposition Products:CO2, CO
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE IN A FURNACE WHERE PERMITTED UNDER
APPROPRIATE FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:BLUE GOOP
Preparer's Name:AT PATIL
CAGE:02570
CAGE:02570
============= Composition/Information on Ingredients =============
Ingred Name:NON-HAZARDOUS INGREDIENTS
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION: NO KNOWN EFFECTS.
SKIN CONTACT: MAY CAUSE SKIN IRRITATION. SKIN ABSORPTION: NOT
READILY ABSORBED THROUGH THE SKIN. EYES: MAY CAUSE IRRITATION.
INGESTION: MAY CAUSE INTERNAL DISTRESS . CHRONIC: NONE OBSERVED.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR AT LEAST 15 MINUTES, SEEK MEDICAL
HELP. SKIN: WASH WITH SOAP AND WATER. INHALATION: UNLIKELY TO BE
INHALED OR CAUSE ILL EFFECTS. REMOVE TO FRESH AIR. SUPPORT
BREATHING (GIVE OXYGEN OR ARTIFICIAL RESPIRATION) . INGESTION:
INDUCE VOMITING, SEEK MEDICAL HELP. NOTES TO MD: INGESTION MAY
CAUSE INTERNAL DISTRESS.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:543F,284C
Lower Limits:NONE
Upper Limits:NONE
Extinguishing Media:WATER SPRAY, DRY CHEMICAL, FOAM OR CARBON DIOXIDE.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL SPILLS MAY BE WIPED UP WITH CLOTH OR
PAPER. USE SHOVEL AND CONTAINER FOR LARGE SPILLS. DISPOSE AS SOLID
WASTE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NO SPECIAL PRECAUTIONS NEEDED FOR
NORMAL USE.
Other Precautions:STORE AWAY FROM HIGH TEMPERATURES AND OPEN FLAME.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED FOR NORMAL USE. USE NIOSH APPROVED
RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:NONE REQUIRED FOR NORMAL USE.
Other Protective Equipment:EMERGENCY EYEWASH AND DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:>90F,>32C
Spec Gravity:1.3 (H*2O=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLUE, OPAQUE PASTE, LITTLE OR NO ODOR
Percent Volatiles by Volume:<0.01
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:AVOID HIGH TEMPERATURES.
Hazardous Decomposition Products:MAY EMIT ORGANO-CHLORINE COMPOUNDS
WHEN EXPOSED TO HIGH TEMPERATURE. COMBUSTION PRODS MAY CONTAIN CO,
CO*2 & ACROLEIN.
==================== Disposal Considerations ====================
Waste Disposal Methods:FOLLOW APPLICABLE LOCAL, STATE AND FEDERAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:NICKEL-CADMIUM (NI-CD) BATTERY,VENTED,BB-613/U
Preparer's Name:CECOM SAFETY OFFICE
CAGE:50120
CAGE:50120
============= Composition/Information on Ingredients =============
Ingred Name:CADMIUM
CAS:7440-43-9
RTECS #:EU9800000
Fraction by Wt: 12%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.1, 0.3(C) MG/M3
ACGIH TLV:0.01 MG/M3 A2
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:COBALT
CAS:7440-48-4
RTECS #:GF8750000
Fraction by Wt: <0.5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.05 MG/M3
ACGIH TLV:0.02 MG/M3 A3, 93-94
Ingred Name:NICKEL
CAS:7440-02-0
RTECS #:QR5950000
Fraction by Wt: 17.5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1 MG/M3
ACGIH TLV:0.05 MG/M3 A1, 93-94
Ingred Name:POTASSIUM HYDROXIDE - 31% SOLUTION
CAS:1310-58-3
RTECS #:TT2100000
Fraction by Wt: 9.5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:2 (C) MG/M3
ACGIH TLV:2 (C) MG/M3
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NOT KNOWN
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INTACT BATTERIES PRESENT NO SPECIFIC
HAZARDS. BURNING BATTERIES MAY EMIT TOXIC FUMES. LEAKING BATTERIES
LEAK CORROSIVE MATERIAL IRRITATING TO SKIN, EYES AND MUCOUS
MEMBRANES.
Explanation of Carcinogenicity:CD & CMPD:LTD EVID FOR CARCIN IN
HUMANS,SUFF IN ANIMALS (IARC 1987);SUSP HUMAN,KNOWN ANIMAL CARCIN
(NTP 1991);(SUP DATA)
Effects of Overexposure:LEAKING BATTERIES LEAK CORROSIVE MATERIAL
IRRITATING TO EYES, SKIN, MUCOUS MEMBRANES. ELECTROLYTE EXPOSURE
TO SKIN, EYES WILL CAUSE SEVERE IRRITATION. INHALATION OF FUMES
MAY CAUSE SEVERE RESPIRATOR Y IRRITATION.
Medical Cond Aggravated by Exposure:BURNING BATTERIES: RESPIRATORY
AILMENTS. LEAKING BATTERIES: SKIN CONDITIONS.
======================= First Aid Measures =======================
First Aid:BATTERY CONTENTS IN CONTACT WITH EYES/SKIN: WASH AFFECTED
AREA WITH CLEAN WATER FOR AT LEAST 15 MINUTES. DO NOT ATTEMPT TO
NEUTRALIZE. SEEK MEDICAL ATTENTION PROMPTLY.
===================== Fire Fighting Measures =====================
Flash Point:NOT KNOWN
Lower Limits:NOT KNOWN
Upper Limits:NOT KNOWN
Extinguishing Media:USE CARBON DIOXIDE OR DRY CHEMICAL FIRE
EXTINGUISHER,10-B:C.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE SELF-CONTAINED
BREATHING APPARATUS (SCBA).
Unusual Fire/Explosion Hazard:BATTERY/CELLS MAY RUPTURE AND/OR RELEASE
TOXIC FUMES,IF SUBJECTED TO FIRE/EXTREME HEAT.FIRE MAY CAUSE
BATTERY TO FUME.
================== Accidental Release Measures ==================
Spill Release Procedures:AVOID SKIN OR EYE CONTACT. USE NONFLAMMABLE
ABSORBENT FOR CLEANUP. COORDINATE WITH INSTALLATION SAFETY AND
ENVIRONMENTAL OFFICES.
Neutralizing Agent:NOT KNOWN
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT ABUSE OR SHORT CIRCUIT. STORE
IN COOL, DRY & WELL VENTILATED AREA, SEPARATE FROM OTHER HAZ MATLS,
WHICH IS APPROVED BY LOCAL FIRE DEPT.
Other Precautions:DO NOT INVERT OR CAUSE TO SPILL. RECHARGE IAW METHODS
SPECIFIED IN APPLICABLE TECHNICAL MANUAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF BATTERIES ARE BURNING USE SELF-CONTAINED
BREATHING APPARATUS (SCBA).
Ventilation:CONTACT LOCAL SAFETY/INDUSTRIAL HYGIENE OFFICE TO DETERMINE
IF LOCAL EXHAUST VENTILATION IS NEEDED .
Other Protective Equipment:CHEMICALLY RESISTANT APRON.
Work Hygienic Practices:AVOID SKIN OR EYE CONTACT WITH ELECTROLYTE. DO
NOT EAT OR SMOKE IN BATTERY SERVICE AREA.
Supplemental Safety and Health
EXPLAN OF CARCIN:ACGIH:A2=SUSP HUMAN CARCIN (1992-93);CHEMICALS KNOWN
TO CAUSE CANCER (PROP CAL 1987).NI/CMPD:SUFF EVID FOR CARCIN IN
HUMANS AND ANIMALS (IARC 1987);SUSPECTED HUMAN,KNOWN ANIMAL CARCIN
OGEN (NTP 1991);ACGIH:A1=CONFIRMED HUMAN CARCIN (1992-93);CHEMICALS
KNOWN TO CAUSE CANCER (PROP CAL 1987).
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:NOT KNOWN
Melt/Freeze Pt:M.P/F.P Text:NOT KNOWN
Decomp Temp:Decomp Text:NOT KNOWN
Vapor Pres:NOT KNOWN
Vapor Density:NOT KNOWN
Spec Gravity:NOT KNOWN
Evaporation Rate & Reference:NOT KNOWN
Solubility in Water:NOT KNOWN
Appearance and Odor:NOT KNOWN
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENT, ACIDS.
Stability Condition to Avoid:FIRE AND EXTREME HEAT. DO NOT SHORT
CIRCUIT OR OVERCHARGE.
Hazardous Decomposition Products:TOXIC FUMES
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IAW FEDERAL,STATE,AND LOCAL
REGULATIONS.COORDINATE WITH SUPPORTING INSTALLATION AND/OR MACOM
ENVIRONMENTAL OFFICE PRIOR TO DISPOSAL .NI-CD BATTERIES CLASSIFIED
AS HAZARDOUS WAST E UNDER RCRA REGULATIONS.RECYCLING IS PREFERRED.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SATCAN FOR SATWIPES PRODUCTS
CAGE:0M3C8
CAGE:0M3C8
============= Composition/Information on Ingredients =============
Ingred Name:THIS PRODUCT IS A 100% HIGH-DENSITY POLYETHYLENE (HDPE)
CONTAINER
======================= First Aid Measures =======================
First Aid:NEVER GIVE FLUIDS OR INDUCE VOMITING IF PATIENT IS
UNCONSCIOUS OR IS HAVING CONVULSIONS. SKIN: NONE NECESSARY.
EYE8/28/2001 NONE NECESSARY. INHALATION: NONE NECESSARY. INGESTION:
NONE NECESSARY.
===================== Fire Fighting Measures =====================
Extinguishing Media:DRY CHEMICAL, WATER, CO2 FOAM.
Fire Fighting Procedures:NIOSH/MSHA APPROVED RESPIRATOR
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:NO SPECIAL RESPONSE REQUIRED.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL PLACE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NECESSARY.
Ventilation:NONE NECESSARY.
Other Protective Equipment:NONE NECESSARY.
Work Hygienic Practices:NONE NECESSARY.
Supplemental Safety and Health
THIS PRODUCT IS NON-HAZARDOUS.
================== Physical/Chemical Properties ==================
HCC:N1
Solubility in Water:INSOLUBLE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:OXIDES OF CARBON AND NITROGEN
=================== Toxicological Information===================
Toxicological Information:NOT APPLICABLE.
===================== Ecological Information =====================
Ecological:NOT APPLICABLE.
==================== Disposal Considerations ====================
Waste Disposal Methods:PRODUCT MAY BE DISPOSED IN A SANITARY LANDFIL.
ALWAYS CONTACT A LICENSED, PERMITTED TREATMENT, STORAGE AND
DISPOSAL FACILITY TO ASSURE COMPLIANCE WITH ALL LOCAL AND STATE
GOVERNMENTAL REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:THIS MATERIAL IS NOT REGULATED.
===================== Regulatory Information =====================
SARA Title III Information:NOT APPLICABLE.
Federal Regulatory Information:NOT APPLICABLE.
======================= Other Information =======================
| 0 | gloves_not_mandatory |
=======================================================
Product ID: ECOSOLVE CLEANING SOLUTION
Cage: 3U331
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 3U331
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: NO
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE: CONTACT WITH SOLUTION MAY CAUSE IRRIT TO SKIN AND
RESP TRACT; SYMPTOMS MAY BE DELAYED FROM MINUTES TO HOURS. EYE CONTACT MAY
CAUSE IRRITATION OR BURNS DEPENDING ON EXPOSURE. CHRONIC: REPEATED C ONTACT
WITH SOLUTION MAY CAUSE DERMATITIS OR CONJUNCTIVITIS.
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: UNKNOWN.
First Aid: EYE:WASH IMMED W/LRG AMTS OF WATER FOR @ LST 15 MIN, OCCASNLY
LIFTING UPPER & LOWER EYELIDS, UNTIL NO EVIDENCE OF CHEM REMAINS.
CONTINUE IRRIGATING W/NORMAL SALINE SOLN UNTIL PH HAS RETURNED TO NORMAL .
COVER W/STERILE BANDAGE & GET MED ATTN IMMED. SKIN:WASH W/SOAP &
WATER UNTIL NO EVIDENCE OF CHEMICAL REMAINS. INHAL:REMOVE FROM EXPOSURE &
TREAT ACCORDING TO SYMPS. INGEST: GET MD IMMED (FP N).
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: PREVENT CONTACT WITH SKIN & EYES; NEUTRALIZE
AND/OR TAKE-UP WITH ABSORBENT MATERIAL AND DISPOSE OF IN ACCORDANCE WITH
LOCAL, STATE AND FEDERAL REGULTIONS.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS.
Handling And Storage Precautions: DO NOT STORE THE CLEANING SOLUTION CONTAINING
THE OXIDIZER (FRESHLY CHARGED) IN A GAS-TIGHT SEALED CONTAINER.
Other Precautions: CONTAINER MAY ACCUMULATE GAS AND BULGE, AND/OR RELEASE GAS
RAPIDLY WHEN OPENED.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: NONFLAMMABLE
Extinguishing Media: DRY CHEMICAL, CARBON DIOXIDE, WATER SPRAY OR REGULAR FOAM.
Fire Fighting Procedures: WEAR NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT (FP N) TO PREVENT CONTACT WITH SKIN.
Unusual Fire/Explosion Hazard: NEGLIGIBLE FIRE HAZARD WHEN EXPOSED TO HEAT OR
FLAME.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NOT NEEDED UNDER NORMAL CONDITIONS OF USE. NIOSH/MSHA
APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN (FP N).
Ventilation: USE IN A WELL VENT AREA. THIS PROD IS INTENDED FOR USE IN
SPECIALLY DESIGNED EQUIPMENT THAT IS LOCALLY (SUPP DATA)
Other Protective Equipment: SAFETY SHOWER AND EYEWASH.
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: MATLS TO AVOID: PRUDENT HEALTH AND SAFETY
PROCEDURES. VENT: EXHAUSTED TO THE OUTSIDE OF A BUILDING. POOR VENTILATION
MAY RESULT IN EXCESSIVE HUMIDITY, INCREASED EXPOSURE TO SOLUTION COMPONENTS,
AND EM PLOYEE DISCOMFORT.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: 212F,100C
M.P/F.P Text: 32F,0C
Vapor Pres: < 18 @ 20C
Vapor Density: < 1
Spec Gravity: 1.0-1.1(H*2O=1)
PH: > 11
Evaporation Rate & Reference: > 1 (BUTYL ACETATE=1)
Solubility in Water: INFINITE
Appearance and Odor: CLEAR, COLORLESS LIQUID WITH A DETERGENT ODOR.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: CNTCT W/CONC ACID CAUSES VIGOROUS BUBBLING AND MAY CAUSE
SPLATTERING. CNTCT W/ACIDS SHLD BE CONTROLLED USING (SUPP DATA)
Hazardous Decomposition Products: DURING A FIRE, THERMAL DECOMP MAY PRODUCE
SULFUR OXIDES, SODIUM OXIDE, CARBON MONOXIDE & CARBON DIOXIDE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: ECOSOLVE CLEANING SOLUTION
Cage: 3U331
Company Name: HUGHES AIRCRAFT CO
Street: 2000 EAST EL SEGUNDO BLVD
Zipcode: 90245
Label Required IND: Y
Date Of Label Review: 03/23/1993
Status Code: C
Label Date: 03/23/1993
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: DO NOT STORE CLEANING SOLUTION CONTAINING THE OXIDIZER
(FRESHLY CHARGED) IN A GAS TIGHT SEALED CONTAINER. CONTAINER MAY ACCUMULATE
GAS. ACUTE: CONTACT WITH SOLUTION MAY CAUSE IRRITATION TO SKIN AND RE
SPIRATORY TRACT. SYMPTOMS MAY BE DELAYED FROM MINUTES TO HOURS. EYE CONTACT
MAY CAUSE IRRITATION OR BURNS DEPENDING ON EXPOSURE. CHRONIC: REPEATED
CONTACT WITH SOLUTION MAY CAUSE DERMATITIS OR CONJUNC TIVITIS.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:IRC 22
Preparer's Name:CORP ENVIRON SERVICES
CAGE:REMIN
CAGE:REMIN
============= Composition/Information on Ingredients =============
Ingred Name:SILICA, CRYSTALLINE - CRISTOBALITE; (CRYSTALLINE SILICA AS
CRISTOBALITE)
CAS:14464-46-1
RTECS #:VV7325000
Fraction by Wt: <5%
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.05 MG/M3 RDUST9293
Ingred Name:SILICA, CRYSTALLINE - QUARTZ; (CRYSTALLINE SILICA AS
QUARTZ)
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: <5%
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
Ingred Name:GROG; (ALUMINO-SILICATES)
CAS:66402-68-4
Fraction by Wt: >40%
Ingred Name:CEMENT BINDER; (CEMENT)
CAS:65997-16-2
Fraction by Wt: <50%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: RPTD/RPLNG CONT W/SKIN CAN
CAUSE IRRIT. MAY IRRITATE/INJURE EYES. CHRONIC: INHAL:LONG TERM
EXPOSURE TO RESPIRABLE SILICA MAY PRDCE PNEUMOCONIOSIS IN
SUSCEPTIBLE PERSONS. CRYSTALLINE SILICA HAS BEEN CATEGORIZED AS A
CLASS 2A CARCINOGEN. A CLASS 2A CARCINOGEN IS ONE IN WHICH THERE IS
LTD EVIDENCE (EFTS OF OVEREXP)
Explanation of Carcinogenicity:CRYSTALLINE SILICA QUARTZ AND
CRISTOBALITE: GROUP 2A (IARC), GROUP 2 (NTP).
Effects of Overexposure:HLTH HAZ: FOR CARCINOGENICITY IN HUMANS AND
SUFFICIENT EVIDENCE FOR CARCINOGENICITY IN EXPERIMENTAL ANIMALS.
Medical Cond Aggravated by Exposure:MAY AGGRAVATE PRE-EXISTING
RESPIRATORY CONDITIONS.
======================= First Aid Measures =======================
First Aid:SKIN: WASH W/SOAP AND PLENTY OF WATER. EYES: IRRIGATE
IMMEDIATELY W/COPIOUS AMOUNTS OF WATER FOR A MINIMUM OF 15 MINUTES.
CONSULT MD IF NECESSARY. INHAL: REMOVE TO FRESH AIR. INGEST: CALL
MD IMMEDIATE LY .
===================== Fire Fighting Measures =====================
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
================== Accidental Release Measures ==================
Spill Release Procedures:USE DUST FREE METHODS OF CLEANUP.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:USE NIOSH/MSHA APPROVED RESPIRATOR IF DUST IS CREATED
DURING HANDLING, INSTALLATION OR TEAROUT. TOXIC RISK MAY BE ALTERED
BY CHEMICAL OR PHYSICAL CHANGES CAUSED BY CONDITIONS OF USE. THIS
PRODUCT IS A GRANULAR REFRACTORY MIX.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESPIRATOR APPROVED BY NIOSH/MSHA AND ADEQUATE
FOR CONTAMINANT CONCENTRATIONS ENCOUNTERED.
Ventilation:LOCAL EXHAUST RECOMMENDED TO MAINTAIN EXPOSURES BELOW TLV'S
AND PEL'S.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:0.5-1.5 (GM/CC)
Solubility in Water:NIL
Appearance and Odor:GREY GRANULAR, DRY; NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:FINAL USED PRODUCT SHOULD BE TESTED TO DETERMINE
HAZARD STATUS AND DISPOSED IN ACCORDANCE W/FEDERAL, STATE AND LOCAL
LAWS AND REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:METHYL HEXADECANOATE, O-431
CAGE:84898
CAGE:84898
CAGE:8Y898
============= Composition/Information on Ingredients =============
Ingred Name:METHYL PALMITATE; (METHYL HEXADECANOATE)
CAS:112-39-0
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CONTACT LENSES SHOULD NOT BE WORN IN
LABORATORY. ALL CHEMICALS SHOULD BE CONSIDERED HAZARDOUS. AVOID
DIRECT PHYSICAL CONTACT! CAN BE HARMFUL IF SWALLOWED. CAN BE
HARMFUL IF INHALED. CAN BE HARMFUL IF ABSORBED THROUGH THE SKIN.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST: ANTIDOTE IS SUBSTANCE INTENDED TO COUNTERACT EFT OF
POIS. IT SHOULD BE ADMIN ONLY BY MD OR TRAINED EMER PERS. MED
ADVICE CAN BE OBTAINED FROM POIS CTL CTR. EYES: FLUSH CONTINUOUSLY
W/WATER FOR AT LEAST 15-20 MIN. SKIN: FLUSH W/WATER FOR 15-20 MIN.
IF NO BURNS HAVE OCCURRED, USE SOAP & WATER TO CLEANSE SKIN. INHAL:
REMOVE TO FRESH AIR. ADMIN OXYGEN IF HAVING DFCLTY BRTHG. IF BRTHG
(SUPDAT)
===================== Fire Fighting Measures =====================
Flash Point:230F,110C
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL POWDER OR WATER SPRAY.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE AREA. WEAR APPROPRIATE OSHA-REGULATED
EQUIPMENT. VENTILATE AREA. ABSORB ON VERMICULITE OR SIMILAR
MATERIAL. SWEEP UP AND PLACE IN AN APPROPRIATE CONTAINER. HOLD FOR
DISPOSAL. WASH CONTAMINATE D SURFACES TO REMOVE ANY RESIDUES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTACT WITH SKIN, EYES AND
CLOTHING. KEEP TIGHTLY CLOSED AND STORE IN A COOL, DRY PLACE. STORE
ONLY WITH COMPATIBLE CHEMICALS.
Other Precautions:PERSONS NOT SPECIFICALLY & PROPERLY TRAINED SHOULD
NOT HANDLE THIS CHEM/ITS CNTNR. PROD IS FURNISHED FOR LAB USE ONLY!
PRODS MAY NOT BE USED AS DRUGS, COSMETICS, AGRICULTURAL OR
PESTICIDAL PRODS, FOOD ADDITIVES OR AS HOUSEHOLD CHEMS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:THIS CHEMICAL SHOULD BE HANDLED ONLY IN A HOOD.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER . USE
APPROPRIATE OSHA/MSMA APPROVED SAFETY EQUIPMENT.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRST AID PROC: HAS STOPPED ADMIN ARTF RESP. IF IN CARD ARREST ADMIN
CPR. CONTINUE LIFE SUPPORTING MEASURES UNTIL MED ASSISTANCE HAS
ARRIVED. GET MED ATTN IF NEC. DO NOT WEAR SHOES/CLTHG UNTIL ABSOLUT
ELY FREE OF ALL CHEM ODORS.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:628F,331C
Melt/Freeze Pt:M.P/F.P Text:>90F,>32C
Spec Gravity:0.852
Appearance and Odor:COLORLESS LIQUID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
COMBUSTIBLE. LOW REACTIVITY. INCOMPATIBLE WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:DECOMPOSITION LIBERATES TOXIC FUMES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH FEDERAL,
STATE AND LOCAL REGULATIONS . BURN IN A CHEMICAL INCINERATOR
EQUIPPED WITH AN AFTERBURNER AND SCRUBBER.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:221 INTERIOR SEMI-GLOSS:XX, 0221
Preparer's Name:PATRICIA SHAW
CAGE:HO931
CAGE:3Z268
CAGE:HO931
============= Composition/Information on Ingredients =============
Ingred Name:PROPIONIC ACID, 2-METHYL-, MONOESTER
W/2,2,4-TRIMETHYL-1,3-PENTANEDIOL. VP:1.0 @ 89F.
CAS:25265-77-4
RTECS #:UF6000000
Fraction by Wt: <5.0%
Ingred Name:1,2 PROPANEDIOL (PROPYLENE GLYCOL). VP:0.2 @ 68F.
CAS:57-55-6
RTECS #:TY2000000
Fraction by Wt: 5%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL:EXCESSIVE OVEREXPOSURE TO VAPORS
OR SPRAY MISTS CAN CAUSE IRRITATION OF EYES, NOSE AND THROAT.
SKIN:MAY CAUSE IRRITATION OR RASH UPON PROLONGED OR REPEATED
CONTACT. EYE:MAY BE AN IRRITANT. INGES T:MAY CAUSE GI IRRITATION,
VOMITING, NAUSEA, OR DIARRHEA. (SEE EFFECTS OF OVEREXPOSURE)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:CHRONIC OVEREXPOSURE TO THIS MATERIAL
MAY LEAD TO SKIN DRYING, RASHES. OVEREXPOSURE TO ITS VAPORS, AS
WHEN IT IS HEATED OR SPRAYED, WILL LEAD TO IRRITATION OF THE NOSE,
THROAT AND LUNGS.
Medical Cond Aggravated by Exposure:DERMATITIS, RESPIRATORY TRACT
IRRITATION.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. EYE:FLUSH WITH LARGE QUANTITIES OF
CLEAN WATER FOR AT LEAST 15 MINUTES AND CALL MD. SKIN:WASH
THOROUGHLY WITH SOAP AND WATER. INGEST:DRINK 1 OR 2 GLASSES OF
WATER TO DILUTE. DO NOT INDUCE VOMITING. CALL MD OR POISON CONTROL
CENTER IMMEDIATELY. TREAT SYMPTOMATICALLY.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:218F,103C
Lower Limits:0.6%
Upper Limits:12.5%
Extinguishing Media:ALCOHOL FOAM, CO*2, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. MATERIAL CAN SPATTER ABOVE 100C/212F.
HEATED MATERIAL CAN BURN.
================== Accidental Release Measures ==================
Spill Release Procedures:KEEP SPECTATORS AWAY. FLOOR MAY BE SLIPPERY,
USE CARE TO AVOID FALLING. DIKE AND CONTAIN SPILL WITH INERT
MATERIAL. TRANSFER LIQUID AND DIKING MATERIAL TO CONTAINERS FOR
RECOVERY AND DISPOSAL. KEEP SP ILLS OUT OF SEWERS AND OPEN WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 100F. KEEP FROM
FREEZING.
Other Precautions:DO NOT TAKE INTERNALLY. KEEP CONTAINERS CLOSED WHEN
NOT IN USE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR SUITABLE FOR
CONCENTRATIONS AND TYPES OF AIR CONTAMINANTS ENCOUNTERED.
Ventilation:MECH LOC EXHST VENT AT POINT OF CONTAM RELEASE W/ADEQ
VOLUME & PATTERN TO MAINTAIN VAP & PARTICULATE LIMITS (SUPP DATA)
Work Hygienic Practices:WASH HANDS AFTER USING. REMOVE WET PAINT FROM
SKIN WITH WATER BEFORE IT DRIES.
Supplemental Safety and Health
VENT:BELOW OSHA PEL OR ACGIH'S TLV LIMIT.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:369F,187C
Vapor Pres:SEE INGRED
Vapor Density:LTR/AIR
Spec Gravity:1.3
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:MISCIBLE
Appearance and Odor:PIGMENTED LIQUID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Hazardous Decomposition Products:UNDER SEVERE THERMAL DEGRADATION, LOW
MOLECULAR WEIGHT HYDROCARBONS MAY BE FORMED.
==================== Disposal Considerations ====================
Waste Disposal Methods:LANDFILL OR INCINERATE ACCORDING TO LOCAL,
STATE, AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ALUMINUM PUTTY (F) RESIN
CAGE:16059
CAGE:16059
============= Composition/Information on Ingredients =============
Ingred Name:BISPHENOL A DIGLYCIDYL ETHER RESIN (MODERATE SKIN
SENSITIZER)
CAS:25068-38-6
Fraction by Wt: 10-30%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 RAT: 11.4 G/KG (EPOXY RESIN)
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: MILD IRRITATION. METAL FILLER
PARTICLES COULD SCRATCH CORNEA. SKIN: MINIMAL TO MILD IRRITATION IN
MOST PEOPLE. INHALATION: UNLIKELY. NO DATA ON SYMPTOMS FOUND.
INGESTION: ALL INGREDIENTS ARE OF LOW ACUTE ORAL TOXICITY. NO DATA
FOUND ON SPECIFIC SYMPTOMS. APPROXIMATLEY 1% OF WORKERS MAY BECOME
SENSITIZED BY TOO
Explanation of Carcinogenicity:NONE
Effects of Overexposure:MUCH SKIN CONTACT WITH EPOXY RESINS; ITCHING,
SWELLING, OR RASHES MAY THEN RESULT FROM FURTHER CONTACT.
Medical Cond Aggravated by Exposure:ALLERGIES, ECZEMA, AND OTHER SKIN
DISORDERS.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH EYE WITH CLEAN WATER FOR AT LEAST 15 MINUTES
WHILE GENTLY HOLDING EYELIDS OPEN. GET MEDICAL ATTENTION. SKIN:
WASH THOROUGHLY WITH SOAP AND WARM WATER. CONSULT A PHYSICIAN IF
IRRITATION DEV ELOPS. INHALATION: REMOVE PATIENT TO FRESH AIR.
ADMINISTER OXYGEN IF BREATHING IS DIFFICULT. GET MEDICAL ATTENTION.
INGESTION: DO NOT INDUCE VOMITING. DILUTE WITH TWO GLASSES OF WATER
& GET MED AID.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>400F,>204C
Extinguishing Media:CO2, DRY CHEMICAL, FOAM
Fire Fighting Procedures:FIREFIGHTERS SHOULD WEAR SELF-CONTAINED
BREATHING APPARATUS AND PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:PREVENT SKIN CONTACT. SCRAPE UP AND DISCARD IN
SUITABLE CONTAINERS, USING INERT ABSORBENT MATERIAL SUCH AS
VERMICULITE IF NEEDED. WASH SPILL AREA WITH AN INDUSTRIAL CLEANING
AGENT. IF SOLVENT IS USED,TAKE CARE AGAINST OVEREXPOSURE & FIRE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE CLOSED IN A COOL, DRY PLACE.
AFTER MIXING W/HARDENER, OBSERVE PRECAUTIONS RECOMMENDED FOR
HARDENER. AFTER PROPER CURING PRODUCT NOT HAZARDOUS.
Other Precautions:LEATHER ARTICLES (SHOES/BELTS) CANNOT BE
DECONTAMINATED, SHOULD BE DISCARDED. WHEN SANDING OR MACHINING
CURED MATERIAL, TAKE PROPER PRECAUTION AGAINST INHALATION OR DUSTS
GENERATED. THESE MAY INCLUDE ALUMINUM, (OBSERVE TLV OF 10 MG/M3).
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED AT NORMAL HANDLING TEMPERATURES.
Ventilation:LOCAL EXHAUST IS RECOMMENDED FOR CONFINED AREAS. GENERAL
MECHANICAL VENTILATION ADEQUATE FOR NORMAL USE.
PROTECTIVE GEAR AS REQUIRED TO PREVENT SKIN CONTACT.
Work Hygienic Practices:REMOVE & CLEAN CONTAM CLOTHES & PROTECTIVE GEAR
BEFORE REUSE. WASH THOROUGHLY AFTER USING ESPECIALLY EATING &
SMOKING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:T6
Vapor Pres:NIL @ 78F
Vapor Density:>1
Spec Gravity:1.92
pH:7.0
Evaporation Rate & Reference:<<1 (BU AC=1)
Solubility in Water:NIL
Appearance and Odor:DARK GRAY PASTE WITH LITTLE ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, BASES AND OXIDIZERS
Stability Condition to Avoid:OPEN FLAME AND EXTREME HEAT
Hazardous Decomposition Products:OXIDES OF CARBON, ALDEHYDES AND ACIDS
FROM INCOMPLETE COMBUSTION.
Conditions to Avoid Polymerization:HEAT IS RELEASED WHEN THIS RESIN IS
MIXED WITH EPOXY HARDENER. USE CAUTION WHEN MIXING A POUND OR MORE.
==================== Disposal Considerations ====================
Waste Disposal Methods:THE RESIN CONTAINS NO RCRA OR CERCLA LISTED
HAZARDOUS WASTES. DISPOSE OF IN ACCORDANCE WITH APPLICABLE STATE
AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CALCIUM NITRATE
CAGE:59896
Contract Num:MDA414-00-P-0004
CAGE:59896
Contract Num:MDA414-00-P-0006
CAGE:59896
Contract Num:MDA414-00-P-4944
CAGE:59896
Contract Num:MDA414-98-A-0118-0125
CAGE:59896
============= Composition/Information on Ingredients =============
Ingred Name:CALCIUM NITRATE
CAS:13477-34-4
RTECS #:EW3000000
= Wt:100.
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50(RAT) = 3900 MG/KG.
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS: NO INFORMATION
AVAILABLE. POTENTAIL HEALTH EFFECTS: EYES: MAY CAUSE IRRITATION.
SKIN: MAY CAUSE IRRITATION. INGESTION: MAY CAUSE GASTROINTESTINAL
DISCOMFORT. INHALATION: MAY CAUSE IRRIT ATION TO RESPIRATORY TRACT.
Effects of Overexposure:EYES: IRRITATION. SKIN: IRRITATION. INHALATION:
IRRITATION OF RESPIRATORY TRACT. INGESTION: GASTROINTESTINAL
DISCOMFORT.
Medical Cond Aggravated by Exposure:NO INFORMATION AVAILABLE.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR AT 15 MINUTES, RAISING UPPER AND
LOWER EYELIDS. GET MEDICAL ATTENTION, IF IRRITATION PERSISTS. SKIN:
WASH EXPOSED SKIN AREA FOR AT LEAST 15 MINUTES. REMOVE CONTAMINATED
CLOT HING. LAUNDER BEFORE REUSE. GET MEDICAL ATTENTION, IF
IRRITATION PERSISTS. INGESTION: IF CONSCIOUS, GIVE PLENTY OF WATER
AND INDUCE VOMITING, AS DIRECTED BY MEDICAL PERSONNEL. CALL
PHYSICIAN OR POISON CONTROL CENTER. NEVER GIVE ANYTHING BY MOUTH
TOUNCONSCIOUS PERSON. GET MEDICAL ATTENTION. INHALATION: MOVE TO
FRESH AIR. GIVE OXYGEN IF BREATHING IS DIFFICULT. GIVE ARTIFICIAL
RESPIRATION IF BREATH ING HAS STOPPED. GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:USE MEDIA SUITABLE TO EXTINGUISH SURROUNDING FIRE.
Fire Fighting Procedures:FIREFIGHTERS SHOULD WEAR FULL PROTECTIVE
EQUIPMENT AND NIOSH APPROVED SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:STRONG OXIDIZER. IN CONTACT WITH EASILY
OXIDIZABLE SUBSTANCE IT MAY REACT RAPIDLY ENOUGH TO CAUSE IGNITION,
VIOLENT COMBUSTION, OR EXPLOSION. INCREASES THE FLAMMABILITY OF
ANY COMBUSTIBLE SUBSTANCE.SHOCK, OR MIXTURE WITH REDUCERS CAN
CAUSE EXPLOSION.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA OF SPILL. CLEAN-UP PERSONNEL
SHOULD WEAR PROPER PROTECTIVE EQUIPMENT. AVOID CREATING DUST. SWEEP
OR SCOOP UP AND CONTAINERIZE FOR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY, WELL-VENTILATED
AREA. STORE AWAY FROM REDUCING AND COMBUSTIBLE MATERIALS. DO NOT
GET IN EYES, ON SKIN, OR ON CLOTHING. WASH THOROUGHLY AFTER
HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NEEDED UNDER NORMAL CONDITIONS OF USE WITH
ADEQUATE VENTILATION. NIOSH APPROVED EQUIPMENT SHOULD BE WORN IF
PELS ARE EXCEEDED.
Ventilation:MECHANICAL TYPE IS ACCEPTABLE. LOCAL EXHAUST IS PREFERRED.
ALL TIMES.
Other Protective Equipment:LAB COAT, EYE WASH STATION, AND SAFETY
SHOWERS.
Work Hygienic Practices:LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
P/N: 85-2180; 85-2208; 85-2210; 84-0910. SIZE 100 GMS AND 500 GMS.
================== Physical/Chemical Properties ==================
HCC:D1
Melt/Freeze Pt:=45.C, 113.F
Vapor Pres:NEGLIGIBLE
Spec Gravity:2.36
Solubility in Water:SOLUBLE
Appearance and Odor:CUBIC, COLORLESS, HYGROSCOPIC, ODORLESS, CRYSTALS.
Percent Volatiles by Volume:NEG AS SOLID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
REDUCING AGENTS AND COMBUSTIBLE MATERIALS.
Stability Condition to Avoid:EXTREME HEAT, SHOCK, CONTACT WITH REDUCING
MATERIALS.
Hazardous Decomposition Products:NITROGEN COMPOUNDS.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
=================== Toxicological Information===================
Toxicological Information:ORAL- RAT LD50: 3900 MG/KG. CHRONIC EFFECTS
OF OVEREXPOSURE: NO CHRONIC EFFECTS DATA FOUND. TARGETORGANS: NO
INFORMATION AVAILABLE. PRIMARY ROUTE(S) OF ENTRY: NO INFORMATION
AVAILABLE.
===================== Ecological Information =====================
Ecological:EPA WASTE NUMBER: D001
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE, AND LOCAL REGULATIONS. ALWAYS CONTACT A PERMITTED
WASTE DISPOSER (TSD) TO ASSURE COMPLIANCE. EPA WASTE NUMBER: D001
=================== MSDS Transport Information ===================
Transport Information:DOT SHIPPING NAME: CALCIUM NITRATE, HAZARD CLASS
5.1, UN1454, PKG I I I.
===================== Regulatory Information =====================
SARA Title III Information:NOT ON SARA SEC. 313 CHEMICALS LIST, SARA
EHS SEC. 302 TPQ, CERCLA SEC. 103 RQ LB, RCRA SEC. 261.33.
Federal Regulatory Information:ON TSCA INVENTORY LIST.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:2,2,4-TRIMETHYLPENTANE, O-741
CAGE:84898
CAGE:84898
CAGE:8Y898
============= Composition/Information on Ingredients =============
Ingred Name:PENTANE, 2,2,4-TRIMETHYL-; (ISO-OCTANE) (CERCLA)
CAS:540-81-1
RTECS #:SA3320000
OSHA PEL:500 PPM (MFR)
ACGIH TLV:383 PPM (MFR)
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ALL CHEMICALS SHOULD BE CONSIDERED
HAZARDOUS - AVOID DIRECT PHYSICAL CONTACT! CAN CAUSE SKIN
IRRITATION. CAN BE IRRITATING TO MUCOUS MEMBRANES. CAN CAUSE EYE
IRRITATION. CAN BE HARMFUL IF ABSORBED THR OUGH SKIN. CAN BE
HARMFUL IF INHALED. CAN BE HARMFUL IF SWALLOWED. NO TOXICITY HAS
BEEN FOUND. ASSUME (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:THIS CHEMICAL IS TOXIC & USE SPECIAL
CARE TO AVOID CONTACT.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD IMMED . EYES:FLUSH CONTINUOUSLY W/WATER FOR AT
LST 15-20 MINS. SKIN:FLUSH W/WATER FOR 15-20 MINS. IF NO BURNS HAVE
OCCURRED-USE SOAP & WATER TO CLEANSE SKIN. INHAL:REMOVE PATIENT TO
FRESH AIR. ADMIN OXYG IF PATIENT IS HAVING DFCLTY BRTHG. IF PATIENT
HAS STOPPED BRTHG ADMIN ARTF RESP. IF PATIENT IS IN CARDIAC ARREST
ADMIN CPR. CONTINUE LIFE SUPPORTING MEASURES UNTIL MED(SUPDAT)
===================== Fire Fighting Measures =====================
Flash Point:10F,-12C
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL POWDER OR WATER SPRAY.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:THIS IS A FLAMMABLE CHEMICAL. NO
EXPLOSION LIMITS ARE AVAILABLE FOR THIS COMPOUND.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE AREA. WEAR APPROPRIATE OSHA-REGULATED
EQUIPMENT. VENTILATE AREA. ABSORB ON VERMICULITE OR SIMILAR
MATERIAL. SWEEP UP & PLACE IN AN APPROPRIATE CONTAINER. HOLD FOR
DISPOSAL. WASH CONTAMINATED SURFACES TO REMOVE ANY RESIDUES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTACT W/SKIN, EYES & CLOTHING.
KEEP TIGHTLY CLOSED & STORE IN A COOL, DRY PLACE. STORE ONLY
W/COMPATIBLE CHEMICALS.
Other Precautions:PERSONS NOT SPECIFICALLY & PROPERLY TRAINED SHOULD
NOT HANDLE THIS CHEM/ITS CNTNR. THIS PROD IS FURNISHED FOR LAB USE
ONLY! PRODS MAY NOT BE USED AS DRUGS, COSMETICS,
AGRICULTURAL/PESTICIDAL PRODS, FO OD ADDITIVES/AS HOUSEHOLD
CHEMICALS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:THIS CHEMICAL SHOULD BE HANDLED ONLY IN A HOOD.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . USE APPROP NIOSH/MSHA APPROVED SAFETY EQUIP.
Work Hygienic Practices:CONTACT LENSES SHOULD NOT BE WORN IN THE
LABORATORY.
Supplemental Safety and Health
FIRST AID PROC:ASSISTANCE HAS ARRIVED. NOTE:AN ANTIDOTE IS A SUBSTANCE
INTENDED TO COUNTERACT EFT OF A POIS. IT SHOULD BE ADMINISTERED
ONLY BY MD/TRAINED EMER PERS. MED ADVICE CAN BE OBTAINED FROM A P
OIS CTL CTR.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:210F,99C
Melt/Freeze Pt:M.P/F.P Text:-161F,-107C
Spec Gravity:0.692
Solubility in Water:INSOL (IMMISCIBLE)
Appearance and Odor:COLORLESS LIQUID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
INCOMPATIBLE W/STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:FLAMMABLE. DECOMPOSITION PRODUCTS ARE
CORROSIVE.
Hazardous Decomposition Products:DECOMPOSITION LIBERATES TOXIC FUMES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS . BURN IN A CHEMICAL INCINERATOR EQUIPPED W/AFTERBURNER
& SCRUBBER.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:P-19 PLASTIC POLISHING & BUFFING COMPOUND
Preparer's Name:H J MCALEER
CAGE:GO738
CAGE:84563
CAGE:GO738
============= Composition/Information on Ingredients =============
Ingred Name:SILICA CRYSTALLINE, TRIPOLI (SUSPECTED HUMAN & ANIMAL
CARCINOGEN BY IARC - GROUP 2A) *98-3*
CAS:1317-95-9
RTECS #:VV7336000
Fraction by Wt: 65-80%
Other REC Limits:30 MG/CUM TOTAL DUST
ACGIH TLV:0.1 MG/CUM
Ingred Name:HYDROGENATED TALLOWS
Ingred Name:ANIMAL FATS, HYDROGENATED
CAS:68953-18-4
Fraction by Wt: 17-32%
Ingred Name:PETROLEUM OIL, HYDROTREATED HEAVY NAPHTHENIC DISTILLATE
(PETROLEUM), PETROLEUM DISTILLATES, MINERAL OIL (SEVERE)
CAS:64742-52-5
RTECS #:PY8035001
Fraction by Wt: 1-2%
Ingred Name:SURFACTANT AMINES
Fraction by Wt: 1-2%
Ingred Name:TRIETHANOLAMINE*98-3*
CAS:102-71-6
RTECS #:KL9275000
ACGIH TLV:5 MG/CUM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHALATION: MAY AFFECT BREATHING
CAPACITY. SKIN: IRRITATION MAY OCCUR DUE TO MECHANICAL/CHEMICAL
ACTION. EYES: MAY IRRITATE. PROLONGED INHALATION OF FREE SILICA,
MAY RESULT IN DISABLING PULMONARY FIBR OSIS. DEPOSITS OF MATERIAL
MAY OCCUR INEYES, EARS, NASAL PASSAGES CAUSING IRRITATION OF MUCOUS
MEMBRANES.
Explanation of Carcinogenicity:SEE INGREDIENTS.
Effects of Overexposure:IRRITATION, COUGHING, SHORTNESS OF BREATH
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR, APPLY ARTIFICIAL RESPIRATION
AS NEEDED. EYES: WASH W/LARGE AMOUNTS OF WATER. OBTAIN MEDICAL
ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:>400F
Extinguishing Media:CO2, DRY CHEMICAL/FOAM
Fire Fighting Procedures:TREAT BUFFING DUST, DIRT & DEBRIS AS AN OIL
FIRE.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP INTO CONTAINERS, STORAGE OF BUFFING
WHEEL & COMPOUND DEBRIS MAY CONTAIN COMBUSTIBLE LINT.
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLE W/ADEQUATE VENTILATION FOR
NUISANCE DUST WHEN USING. KEEP LIQUIDS FROM FREEZING. ALWAYS STORE
FROM EXCESSIVE HEAT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:OSHA 24 CFR/134 NIOSH/MSHA APPROVED RESPIRATORS
FOR PARTICULATES FROM BUFFING DEBRIS.
Ventilation:LOCAL EXHAUST: GENERAL ROOM VENTILATION. MECHANCIAL
(GENERAL) RECOMMED VENTING TO DUST COLLECTORS
Other Protective Equipment:PROTECTIVE WORK CLOTHING, BODY APRON/BELLY
PADS, SAFETY SHOES
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>300F
Melt/Freeze Pt:M.P/F.P Text:145F
Spec Gravity:1.5
Solubility in Water:INSOLUBLE
Appearance and Odor:HARD CAKE W/BLAND GREASE ODOR
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS/REDUCING AGENTS
Hazardous Decomposition Products:SMOKE, CO2, CO
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE/DISPOSE OF IN ACCORDANCE W/LOCAL,
STATE & FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:1650-98710 S.O.S. GLASS WORKS
Preparer's Name:M.M. BYRNES
CAGE:6N841
CAGE:6N841
============= Composition/Information on Ingredients =============
Ingred Name:2-BUTOXYETHANOL
CAS:111-76-2
RTECS #:KJ8575000
Other REC Limits:25 PPM (SKIN)
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM; 9293
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MATERIAL IS NON-TOXIC & IRRITATING.
Explanation of Carcinogenicity:NONE
======================= First Aid Measures =======================
First Aid:NONE REQUIRED
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:NONE
Extinguishing Media:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:WASH AREA W/WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:MFG: RESPIRATORY MASK WHEN HANDLING;
CONSUMER: NONE.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE
Ventilation:USE IN AN AREA W/ADEQUATE VENTILATION
Other Protective Equipment:NONE
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:208F
Spec Gravity:0.9940
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR GREEN LIQUID W/PROPRIETARY FLOWERY/FRUITY
FRAGRANCE.
Percent Volatiles by Volume:100%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NOT RECOMMENDED FOR FINISHED WOOD SURFACES
==================== Disposal Considerations ====================
Waste Disposal Methods:END USE PRODUCT CONTAINER SHOULD BE DISCARDED IN
TRASH.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:POWER PLUS 12
CAGE:UNVER
CAGE:UNVER
============= Composition/Information on Ingredients =============
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
Ingred Name:ALUMINUM SILICATE
CAS:1302-76-7
RTECS #:BD1450000
OSHA PEL:15 MG/M3 (MFR)
ACGIH TLV:5 MG/M3 (MFR)
Ingred Name:COAL FLY ASH; (FLY ASH)
CAS:68131-74-8
RTECS #:GF8285000
OSHA PEL:15 MG/M3 (MFR)
ACGIH TLV:5 MG/M3 (MFR)
Ingred Name:MINERAL WOOLS; (MINERAL WOOL)
CAS:65996-69-2
OSHA PEL:15 MG/M3 (MFR)
ACGIH TLV:10 MG/M3
Ingred Name:SILICATE, PORTLAND CEMENT; (PORTLAND CEMENT)
CAS:65997-15-1
RTECS #:VV8770000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE/CHRONIC: PROLONGED EXPOSURE TO
HIGH CONCENTRATIONS OF CRYSTALLINE SILICA CAN CAUSE SILICOSIS.
PROLONGED INHALATION OF DUST MAY CAUSE PNEUMOCONIOSIS.
Explanation of Carcinogenicity:SILICA, CRYSTALLINE - QUARTZ:IARC
MONOGRAPHS, SUPPLEMENT, VOL 7, PG 341, 1987:GROUP 2A. NTP 6TH
ANNUAL REPORT (SUP DAT)
Effects of Overexposure:COUGH & IMPAIRED PULMONARY FUNCTION.
Medical Cond Aggravated by Exposure:RESPIRATORY DISEASES.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/WATER FOR AT LEAST 15 MINS. SKIN:FLUSH W/WATER.
INHAL:FRESH AIR. INGEST:CONSULT MD.
===================== Fire Fighting Measures =====================
Extinguishing Media:NON-COMBUSTIBLE. USE MEDIA SUITABLE FOR SURROUNDING
FIRE CONDITIONS .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:NORMAL CLEAN-UP.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE UNDER DRY CONDITIONS AT ROOM
TEMPERATURE.
Other Precautions:NONE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATORY EQUIPMENT (E.G.
3M8710). WEAR NIOSH/MSHA APPROVED RESPIRATORS DURING TEAR OUTS.
Ventilation:LOCAL EXHAUST TO MAINTAIN BELOW PEL.
Other Protective Equipment:NONE.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EXPLAN OF CARCIN:ON CARCINOGENS, 1991:ANTICIPATED TO BE A CARCINOGEN
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:2.8 (H*2O=1)
Solubility in Water:NONE
Appearance and Odor:GRAY SOLID; ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NOT APPLICABLE.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:NORMAL DISPOSAL (I.E. LANDFILL IN ACCORDANCE
W/FEDERAL, STATE & LOCAL REGULATIONS).
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:WATERLESS HAND CLEANER WITH PUMICE, 381081
Preparer's Name:RONALD A WILLIAMS
CAGE:1T674
CAGE:1T674
============= Composition/Information on Ingredients =============
Ingred Name:NAPHTHA, HEAVY ALKYLATE; (ISOPARAFFIN)
CAS:64741-65-7
Fraction by Wt: <10%
OSHA PEL:300 PPM
ACGIH TLV:300 PPM
Ingred Name:MINERAL OIL, WHITE
CAS:8042-47-5
RTECS #:PY8047000
Fraction by Wt: <15%
OSHA PEL:5 MG/M3 MFR
ACGIH TLV:5 MG/M3 MFR
Ingred Name:NONIONIC SURFACTANT
CAS:68145-97-2
Fraction by Wt: <10%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SCRUBBING PARTICLES
Fraction by Wt: <10%
OSHA PEL:5 MG/M3 MFR
ACGIH TLV:5 MG/M3 MFR
Ingred Name:1,2-PROPANEDIOL; (PROPYLENE GLYCOL)
CAS:57-55-6
RTECS #:TY2000000
Fraction by Wt: <10%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SIGNS AND SYMPTOMS OF
OVEREXPOSURE:EYE:IRRITATION. INGEST:GASTRIC DISTRESS.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTF
RESP) . SKIN:FLUSH W/COPIOUS AMOUNTS OF WATER. CALL MD . EYES:DO
NOT RUB EYES, FLUSH WITH WATER FOR AT LEAST 15 MINUTES, IF IRRI
TATION PERSISTS, CONTACT PHYSICIAN. INGEST:DO NOT INDUCE VOMITING,
CONTAINS ISOPARAFFIN AND MINERAL OIL. CONTACT PHYSICIAN OR POISON
CONTROL CENTER IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:>125F,>52C
Extinguishing Media:WATER FOG, ALCOHOL FOAM, CO*2, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE KNOWN.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB AND COLLECT FOR DISPOSAL. FLUSH AREA
WITH WATER TO REDUCE POSSIBLE FLOOR "SLIP" HAZARD.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID EYE CONTACT; STORE AT AMBIENT
CONDITIONS.
Other Precautions:KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED. USE NIOSH/MSHA APPROVED
RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:NONE REQUIRED.
Other Protective Equipment:NONE REQUIRED.
Work Hygienic Practices:ROUTINE.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Spec Gravity:CA 0.88(H*2O=1)
Solubility in Water:CA 45%
Appearance and Odor:GREEN OPAQUE GEL, PLEASANT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:NONE KNOWN.
==================== Disposal Considerations ====================
Waste Disposal Methods:ACCORDING TO ALL LOCAL, STATE AND FEDERAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:48201-1 TO -1 BIG BARE 4100
Preparer's Name:TERRY A MEYERS
CAGE:0U826
CAGE:0U826
CAGE:32204
============= Composition/Information on Ingredients =============
Ingred Name:NONYLPHENOXYPOLY-(ETHYLENEOXY) ETHANOL, NP-9, NONIONIC
SURFACTANT
CAS:26027-38-3
RTECS #:MD0906000
Fraction by Wt: <1%
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: <95%
Ingred Name:SODIUM HYDROXIDE, CAUSTIC SODA, LYE
CAS:1310-73-2
RTECS #:WB4900000
Fraction by Wt: <0.5%
Other REC Limits:2MG/M3 CEILING NIOSH
OSHA PEL:2 MG/CUM
ACGIH TLV:2 MG/CUM CEILING
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: MODERATE IRRITATION. SKIN:
IRRITATION. PRODUCT MAY CAUSE DISTRESS & ILLNESS IF TAKEN
INTERNALLY. PRODUCT SPRAY MIST, FOG/VAPOR MAY CAUSE IRRITATION TO
NOSE, THROAT & LUNGS IF ADEQUATE VENTILATIO N IS NOT EMPLOYED.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN DISORDERS MAY BE
MORE SUSCEPTIBLE TO IRRITATING EFFECTS.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR 15-20 MINS. SKIN: REMOVE W/SOAP &
WATER. INGESTION: DRINK LARGE AMOUNTS OF WATER/MILK. INHALATION:
REMOVE TO FRESH AIR & VENTILATE AREA. OBTAIN MEDICAL ATTENTION IN
ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:FOAM, CO2, DRY CHEMICAL, WATER FOG
Fire Fighting Procedures:NORMAL FIRE FIGHTING PROCEDURES MAY BE USED.
COOL & USE CAUTION WHEN APPROACHING/HANDLING FIRE EXPOSED
CONTAINERS.
Unusual Fire/Explosion Hazard:CONTAINER MAY MELT & LEAK IN HEAT OF
FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB W/OIL-DRI/SIMILAR INERT MATERIAL.
SWEEP/SCRAPE UP & CONTAINERIZE. RINSE AFFECTED AREA THOROUGHLY
W/WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:PRODUCT RESIDUE MAY REMAIN IN/ON EMPTY
CONTAINERS. PRECAUTIONARY MEASURES SHOULD BE TAKEN WHEN HANDLING
EMPTY CONTAINER & RESIDUES.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. AVOID CONTACT
W/EYES/SKIN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:LOCAL VENTILATION, USE APPROPRIATE RESPIRATORY
PROTECTION TO PREVENT OVEREXPOSURE
Ventilation:GENERAL ROOM VENTILATION IS ADEQUATE. LOCAL EXHAUST
VENTILATION/RESPIRATORY PROTECTION TO CONTROLL SUBSTANTIAL VAPORS.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>200F
Melt/Freeze Pt:M.P/F.P Text:32F
Spec Gravity:1.01
pH:12.5
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR WATER-WHITE LIQUID W/MILD ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS (E.G. MURIATIC ACID)
Stability Condition to Avoid:FREEZING
Hazardous Decomposition Products:WHEN EXPOSED TO FIRE, PRODUCES NORMAL
PRODUCTS OF COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SIGMA EDGEGUARD BASE, 5428A
Preparer's Name:JAY FOLSE
CAGE:1K005
CAGE:1K005
============= Composition/Information on Ingredients =============
Ingred Name:NEPHELINE SYENITE
CAS:37244-96-5
Minumum % Wt:10.
Maxumum % Wt:25.
OSHA PEL:NOT AVAILABLE
OSHA STEL:NOT AVAILABLE
ACGIH TLV:TWA 10 MG/M3
ACGIH STEL:NOT AVAILABLE
Ingred Name:POWDERED THIXOTROPIC ADDITIVE
Minumum % Wt:1.
Maxumum % Wt:10.
OSHA PEL:NOT AVAILABLE
OSHA STEL:NOT AVAILABLE
ACGIH TLV:NOT AVAILABLE
ACGIH STEL:NOT AVAILABLE
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Minumum % Wt:1.
Maxumum % Wt:10.
OSHA PEL:10 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:MAGNESIUM SILICATE
CAS:14807-96-6
RTECS #:WW2710000
Minumum % Wt:1.
Maxumum % Wt:10.
OSHA PEL:TWA 2 MG/M3R DUST
OSHA STEL:NOT AVAILABLE
ACGIH TLV:TWA 2 MG/M3 R DUST
ACGIH STEL:NOT AVAILABLE
Ingred Name:EPOXY RESIN
CAS:28064-14-4
Minumum % Wt:50.
Maxumum % Wt:75.
OSHA PEL:NOT AVAILABLE
OSHA STEL:NOT AVAILABLE
ACGIH TLV:NOT AVAILABLE
ACGIH STEL:NOT AVAILABLE
Ingred Name:BENZYL ALCOHOL
CAS:100-51-6
RTECS #:DN3150000
Minumum % Wt:10.
Maxumum % Wt:25.
OSHA PEL:NOT AVAILABLE
OSHA STEL:NOT AVAILABLE
ACGIH TLV:NOT AVAILABLE
ACGIH STEL:NOT AVAILABLE
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:THIS PRODUCT CAN BE IRRITATING TO THE
EYES. THIS PRODUCT MAY CAUSE IRRITATION TO THE UPPER RESPIRATORY
TRACT. BASED ON THE PRESENCE OF EPOXY RESIN THIS PRODUCT MAY CAUSE
SKIN IRRITATION, ALLERGIC REAC TION AND SENSITIZATION. A COMPONENT
OF THIS PRODUCT CAUSE DIZZINESS, HEADACHE, LOSS OF BALANCE,
COUGHING, PULMONARY EDEMA, NAUSEA,VOMITING, KIDNEY AND LIVER
DAMAGE. CARDIAC ARRHYTHMIA LEADING TO DEA TH MAY OCCUR IN SENSITIVE
INDIVIDUALS. MAY HAVE EFFECTS ON THE DEVELOPING FETUS. THIS PRODUCT
CAN BE ABSORBED THROUGH THE SKIN CAUSING ORGAN DAMAGE. IN A 2 YEAR
STUDY IN RATS, AN INCREASE IN BENIGN & MALIGNANT LUNG TUMORS
(SIGNS & SYMPTOMS)
Explanation of Carcinogenicity:THIS PRODUCT CONTAINS NO REPORTED
CARCINOGENS OR SUSPECTED CARCINOGENS.
Effects of Overexposure:HEALTH HAZARDS ACUTE AND CHRONIC (CONT'D): WAS
OBSERVED AT 250 MG/CUBIC METER RESPIRABLE DUST LEVEL. THIS IS 50
TIMES THE CURRENT OCCUPATIONAL LEVEL AND IS NOT EXPECTED TO
CORRELATE TO HUMANS. NOTICE : REPORTS HAVE ASSOCIATED REPEATED AND
PROLONGED OCCUPATIONAL OVEREXPOSURE TO SOLVENTS WITH PERMANENT
BRAIN AND NERVOUS SYSTEM DAMAGE. INTENTIONAL MISUSE BY DELIBERATELY
CONCENTRATING AND INHALING THE CONTENTS MAY BE HARMFUL OR FATAL.
Medical Cond Aggravated by Exposure:SKIN DISORDERS AND ALLERGIES.
======================= First Aid Measures =======================
First Aid:EYE CONTACT: FLUSH WITH WATER FOR 15 MINUTES. SEEK PHYSICIAN
IMMEDIATELY. SKIN CONTACT: FLUSH WASH WITH COPIUS AMOUNTS OF WATER.
REMOVE CONTAMINATED CLOTHING PROMPTLY. CONTACT A PHYSICIAN
IMMEDIATELY. INHALATION: REMOVE EXPOSED INDIVIDUAL TO FRESH AIR.
RESTORE BREATHING IF REQUIRED. CONTACT A PHYSICIAN IMMEDIATELY.
INGESTION: RINSE MOUTH IMMEDIATELY. GIVE EXPOSED INDIVIDUAL 6 TO 8
OUNCES OF LIQUID . (NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS
PERSON). DO NOT INDUCE VOMITING UNLESS ADVISED BY A PHYSICIAN.
CONTACT A PHYSICIAN IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point:=93.3C, 200.F
Extinguishing Media:USE CO2, DRY CHEMICAL, FOAM, ALCOHOL FOAM, OR WATER
FOG.
Fire Fighting Procedures:WATER SPRAY MAY BE INEFFECTIVE. WATER MAY BE
USED TO COOL CLOSED CONTAINERS TO PREVENT PRESSURE BUILDUP AND
POSSIBLE AUTOIGNITION OR EXPLOSION WHEN EXPOSED TO EXTREME HEAT. IF
WATER USED, FOG NOZZLES ARE PREFERABLE. HEAVIER-THAN-AIR VAPORS
CAN FLOW ALONG SURFACES TO DISTANT IGNITION SOURCES AND FLASH BACK.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE
FROM HEAT, ELECTRICAL EQUIPMENT, SPARKS, OPEN FLAMES. CLOSED
CONTAINER MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT. USE SPECIAL
PRECAUTIONS TO APPLY TO HOT SURFACE S. DO NOT USE WELDING OR
CUTTING TORCH ON OR NEAR CONTAINER (EVEN EMPTY) BECAUSE LIQUID
PRODUCT MAY IGNITE EXPLOSIVELY.
================== Accidental Release Measures ==================
Spill Release Procedures:STAY UPWIND FROM SPILL UNLESS WEARING
PROTECTIVE EQUIPMENT. STOP AND/OR CONTAIN DISCHARGE. KEEP SOURCES
OF IGNITION AWAY. VENTILATE SPILL AREA. USE NON-SPARKING TOOLS FOR
CLEANIUP. COVER WITH INERT MA TERIAL TO REDUCE FUMES. KEEP OUT OF
DRAINS, SEWERS, WATERWAYS. CONTACT FIRE AUTHORITIES. NOTIFY LOCAL
HEALTH AND POLLUTION CONTROL AGENCIES. CALL SPILL RESPONSE TEAMS IF
LARGE SPILL.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID INHALATION OF VAPORS. AVOID
PERSONAL CONTACT WITH PRODUCT. IF CONTACT MADE, REMOVE SATURATED
CLOTHING & FLUSH AFFECTED SKIN WITH WATER. EMPTIED CONTAINERS MAY
BE HAZARDOUS. SINCE EMPTIED CONTAIN ERS RETAIN PRODUCT RESIDUES
(VAPOR, LIQUID, &/OR SOLID). ALL HAZARD PRECAUTIONS SHOULD BE
OBSERVED.
Other Precautions:KEEP CONTAINERS TIGHTLY CLOSED. USE SPECIAL
PRECAUTIONS TO APPLY TO HOT SURFACES. DO NOT USE WELDING OR CUTTING
TORCH ON OR NEAR CONTAINER (EVEN EMPTY) BECAUSE LIQUID PRODUCT MAY
IGNITE EXPLOSIVELY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF EXPOSURE EXCEEDS TLV, USE A NIOSH-APPROVED
RESPIRATOR. IN OUTDOOR OR OPEN AREAS USE NIOSH-APPROVED MECHANICAL
FILTER RESPIRATOR TO REMOVE SOLID AIRBORNE PARTICLES OF OVERSPRAY.
IN RESTRICTED VENTIL ATION AREAS USE NIOSH-APPROVED
CHEMICAL-MECHANICAL FILTERS. IN CONFINED AREAS USE NIOSH-APPROVED
AIR LINE TYPE RESPIRATORS OR HOODS.
Ventilation:USE VENTILATION AS REQUIRED TO CONTROL VAPOR
CONCENTRATIONS.
BUNA N OR NITRILE.
OF EYE CONTACT .
Other Protective Equipment:AN APRON SHOULD BE WORN TO AVOID SKIN
CONTACT.
Work Hygienic Practices:WASH HANDS THROUGHLY BEFORE EATING AND USING
WASHROOM. AVOID CONTACT WITH EYES. AVOID PROLONGED OR REPEATED
BREATHING OF VAPORS.
Supplemental Safety and Health
REPORTS HAVE ASSOCIATED REPEATED AND PROLONGED OCCUPATIONAL
OVEREXPOSURE TO SOLVENTS WITH PERMANENT BRAIN AND NERVOUS SYSTEM
DAMAGE. INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING AND
INHALING THE C ONTENTS MAY BE HARMFUL OR FATAL.
================== Physical/Chemical Properties ==================
Boiling Pt:=205.C, 401.F
Vapor Pres:0.100
Vapor Density:3.720
Spec Gravity:1.4330
Evaporation Rate & Reference:0.0000 (ETHER=1)
Appearance and Odor:APPEARANCE: LIQUID. ODOR: NOT IRRITATING.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
THIS PRODUCT IS INCOMPATIBLE WITH STRONG OXIDIZING AGENTS; CONTACT WITH
THESE MATERIALS MAY CAUSE FIRE OR EXPLOSION.
=================== Toxicological Information===================
Toxicological Information:TITANIUM DIOXIDE (CAS # 13463-67-7) LD50,
SKIN RABBITS: OVER 10,000 MG/KG. BENZYL ALCOHOL (CAS # 100-51-6)
LD50, ORAL, RAT: 1,230 MG/KG; LC50: =1,000 PPM, LEL = 1.30.
LD50/LC50 FOR ALL OTHER INGREDIE NTS : NOT AVAILABLE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH APPLICABLE FEDERAL,
STATE AND LOCAL REGULATIONS .
===================== Regulatory Information =====================
SARA Title III Information:SARA 313 INFORMATION: THIS PRODUCT CONTAINS
NONE OF THE SUBSTANCES SUBJECT TO THE REPORTING REQUIREMENTS OF
SECTION 313 OF TITLE I I I OF THE SUPERFUND AMENDMENTS AND
REAUTHORIZATION ACT OF 1986 AND 4 0 CFR PART 372.
State Regulatory Information:CALIFORNIA PROPOSITION 65 REQUIRES
MANUFACTURERS TO WORN USERS OF THE PRESENCE OF CHEMICALS WHICH MAY
CAUSE A "SIGNIFICANT RISK". BASED UPON THE POSSIBILITY OF THE
PRESENCE OF MINUTE AMOUNTS OF CONTAM INANTS IN ANY PAINT, SIGMA
COATINGS GIVES THE FOLLOWING WARNINGS: WARNING: THIS PRODUCT
CONTAINS A CHEMICAL KNOWN TO THE STATE OF CALIFORNIA TO CAUSE
CANCER. WARNING: THIS PRODUCT CONTAINS A CHEMICAL KNOWN TO THE
STATE OF CALIFORNIA TO CAUSE BIRTH DEFECTS OR OTHER REPRODUCTIVE
HARM.
======================= Other Information =======================
| 1 | gloves_mandatory |
=======================================================
Product ID: SUPER STRENGTH ADHESIVE, 6004
Cage: 1BY21
=======================================================
Contractor Summary
=======================================================
Cage: 76381
Cage: 1BY21
=======================================================
Ingredients
=======================================================
Cas: 78-93-3
RTECS #: EL6475000
% Wt: 59-60
OSHA PEL: 200 PPM;300 PPM STEL
ACGIH TLV: 200 PPM;300 PPM STEL
EPA Rpt Qty: 5000 LBS
DOT Rpt Qty: 5000 LBS
------------------------------
Cas: 9005-09-8
% Wt: 25-35
------------------------------
% Wt: 5-10
-----------------------------
Cas: 25068-38-6
RTECS #: SL6475000
% Wt: <0.5
------------------------------
RTECS #: 9999999VO
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: LD50:(ORAL,RAT)>5 GM/KG
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE: EYE: LIQ IS IRRITATING TO EYES ON DIRECT CONT.
SKIN: LIQ IS NOT EXPECTED TO BE IRRITATING TO SKIN FROM LIM CONT. PRLNGD CONT
MAY CAUSE DRY & CRACKING. INHAL: WHILE FOLLOWING EFTS ARE ASSOC W/ON
E/MORE OF INDIVIDUAL INGRED IN PROD & ARE REQD TO BE INCLUDED ON MSDS BY
U.S. OSHA HAZ COMMUNICATION (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: HLTH HAZ: STD, THEY ARE NOT EXPECTED EFTS
DURING FORESEEABLE USE OF PROD. DUE TO SM CONTR SIZE, NO INHAL HAZ IS
EXPECTED UNDER LOW VOL USAGE. HIGH CONC OF VAPS MAY CAUSE RESP SYS IRRIT
& TEMP NERV SYS IMPAIRMENT. SYMPS OF OVEREXP MAY INCL DIZZ, WEAK, FATG,
NAUS, HDCH, INCOORD & IN EXTREME OVEREXP UNCON. (SUPP DATA)
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: EYE: IMMED FLUSH WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES. CALL
A PHYSICIAN. SKIN: WASH AFFECTED AREA WITH SOAP AND WATER. INHAL: REMOVE TO
FRESH AIR. IF SYMPTOMS CONTINUE, CALL A PHYSICIAN. INGES T: DO NOT INDUCE
VOMITING. GIVE 1-2 GLASSES OF WATER. IMMED CALL A PHYSICIAN OR POISON
INFORMATION CENTER.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: OBSERVE PREC INFO. EXTING ALL IGNIT SOURCES. VENT
AREA. APPLY ABSORB MATL TO AREA OF SPILL. CNTN SPILL. COLLECT SPILL. CLEAN UP
RESIDUE. PLACE IN A U.S. D.O.T.-APPRVD CONTR & SEAL. FOREGOING IS RECOMM
ENDATION FOR LARGE QTY SPILL.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: FOR BULK QTY: INCIN IN A PERMITTED HAZ WASTE FACILITY.
SINCE REGULATIONS VARY, CONSULT APPLIC FED, ST & LOC REGS/AUTH BEFORE
DISPOSAL. U.S. EPA HAZARDOUS WASTE NO. D-081(IGNITABLE).
Handling And Storage Precautions: KEEP PROD & VAPS AWAY FROM HEAT, SPARKS
& OPEN FLAME. USE ONLY IN WELL VENTD AREA W/ENOUGH AIR MOVEMENT TO REMOVE
VAPOS. AVOID PRLNGD BRTHG OF VAPS.
Other Precautions: AVOID EYE AND SKIN CONTACT. KEEP TUBE CLOSED WHEN NOT IN
USE. KEEP OUT OF REACH OF CHILDREN.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: TCC
Flash Point Text: 20.0F,-6.7C
Lower Limits: 1.8%
Upper Limits: 11.5%
Extinguishing Media: CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures: WEAR NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: EXTREMELY FLAMMABLE LIQUID.
=======================================================
Control Measures
=======================================================
Respiratory Protection: USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN (FP N).
Ventilation: NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment: NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: EFTS OF OVEREXP: INGEST: IF SWALLWOED &
VOMIT OCCURS OF LIQ INTO LUNGS MAY OCCUR RSLTG IN CHEM PNEUM WHICH CAN BE
FATAL. PROD IS EXPECTED TO BE PRACTICALLY NONTOX ORALLY.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: 177F,81C
Vapor Pres: 80@20C
Vapor Density: 2.50
Spec Gravity: 0.95(H*2O=1)
Evaporation Rate & Reference: 2.70(ETHER=1)
Solubility in Water: SLIGHT
Appearance and Odor: VISCOUS LIQUID, CLEAR, KETONE ODOR
Percent Volatiles by Volume: 68
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: NOT DETERMINED.
Hazardous Decomposition Products: THERMAL DECOMP OR BURNING MAY PRODUCE CARBON
MONOXIDE, CARBON DIOXIDE, AND OTHER LOW MOLECULAR WEIGHT HYDROCARBONS.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: SUPER STRENGTH ADHESIVE, 6004
Cage: 1BY21
Company Name: MINNESOTA MINING AND MFG CO ENGINEERING DOCUMENT SYSTEMS DIV
Street: 3M CTR
Zipcode: 55144-1000
Label Required IND: Y
Date Of Label Review: 04/08/1993
Status Code: C
Label Date: 04/08/1993
Origination Code: G
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: Severe
Reactivity Hazard: None
Hazard And Precautions: FLAMMABLE. KEEP AWAY FROM HEAT, SPARKS AND FLAME.
ACUTE: INHALATION MAY CAUSE DIZZINESS, WEAKNESS, FATIGUE, NAUSEA, HEADACHE,
INCOORDINATION. MAY CAUSE EYE AND SKIN IRRITATION. CHRONIC: NONE SPECIFIED
BY MANUFACTURER.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MCLUBE 1700
CAGE:FO077
CAGE:04672
CAGE:FO077
============= Composition/Information on Ingredients =============
Ingred Name:METHYL CHLOROFORM (1,1,1-TRICHLOROEHANE) (SARA III)
CAS:71-55-6
RTECS #:KJ2975000
Fraction by Wt: 80.0%
OSHA PEL:350 PPM/450 STEL
ACGIH TLV:350 PPM/450STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ozone Depleting Chemical:1
Ingred Name:2-ETHOXYETHYL ACETATE (CELLOSOLVE ACETATE) (EGEEA)
CAS:111-15-9
RTECS #:KK8225000
Fraction by Wt: 3.0%
OSHA PEL:S,100 PPM
ACGIH TLV:S, 5 PPM; 9192
Ingred Name:ISOPROPYL ALCOHOL (SARA III)
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 2.0%
OSHA PEL:400 PPM/500 STEL
ACGIH TLV:400 PPM/500STEL;9192
===================== Hazards Identification =====================
Effects of Overexposure:LIGHT HEADEDNESS, SHORTNESS OF BREATH, POSSIBLE
NARCOSIS
======================= First Aid Measures =======================
First Aid:SOLVENT INH: REMOVE TO FRESH AIR,CALL MD. DO NOT GIVE
EPINEPHRINE OR SIMILAR DRUGS.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WATER/FOG
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:BURNING CAN GENERATE HAZ FUMES REQ RESP
================== Accidental Release Measures ==================
Spill Release Procedures:VENT AREA, WIPE UP SPILL AS AREA CAN BECOME
SLIPPERY.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID TEMP EXTREMES. CNTNRS MAY
DEVELOP PRESSURE. AVOID CONTAM OF TOBACCO PROD W/SOLIDS.
Other Precautions:IF PROD SOLD IN AEROSOL, AVOID DIRECT INH OF VAPORS.
DO NOT STORE ABOVE 120F. PROPELLANT IS DICHLORODIFLUOROMETHANE. USE
SPECIAL VENT IF TEMP EXCEEDS 400F.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AIR MASK IF VAPOR CONC IS HIGH
Ventilation:LOCA EXH, REC. MECH/GEN, MAINTAIN TLV
Other Protective Equipment:POSITIVE VENT
Supplemental Safety and Health
MFR ADDRESS: 9 CROZERVILLE RD. ASTON, PA 19014.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:165F
Vapor Pres:100
Vapor Density:4.5
Spec Gravity:1.3
Evaporation Rate & Reference:2.5 ETHER
Solubility in Water:NEGLIGIBLE
Appearance and Odor:WHITE TRANSLUCENT DISPERSION, SLIGHT ETHERIAL ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALKALI OR ALKALINE EARTH METALS
Stability Condition to Avoid:AVOID BURNING IN OPEN FLAMES
Hazardous Decomposition Products:HCL, HF, PHOSGENE, CO, PFIB, OTHER ORG
FLUORIDES, POSS >400F
==================== Disposal Considerations ====================
Waste Disposal Methods:SOLVENT WILL EVAPORATE, SOLID WASTE SHOULD BE
BURIED.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PS-775 METHOMYL
CAGE:84898
CAGE:84898
CAGE:8Y898
============= Composition/Information on Ingredients =============
Ingred Name:METHOMYL (LANNATE)(SARA III)
CAS:16752-77-5
RTECS #:AK2975000
Fraction by Wt: 99%
OSHA PEL:2.5 MG/M3
ACGIH TLV:2.5 MG/M3; 9192
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (RAT OR MOUSE): 17 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: FATAL IF ABSORBED. EYES: BURNS.
INHALATION: FATAL, POSSIBLE CHOLINESTERASE INHIBITOR, SEIZURES,
NAUSEA, VOMITING, AIRWAY OBSTRUCTION &/OR INCREASED MUCOUS
SECRETIONS IN THE LUNGS. INGESTION: FAT AL.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SKIN: FATAL IF ABSORBED. EYES: BURNS.
INHALATION: FATAL, POSSIBLE CHOLINESTERASE INHIBITOR, SEIZURES,
NAUSEA, VOMITING, AIRWAY OBSTRUCTION &/OR INCREASED MUCOUS
SECRETIONS IN THE LUNGS. INGESTION: FAT AL.
======================= First Aid Measures =======================
First Aid:EYES/SKIN: FLUSH W/WATER FOR 15-20 MINS. IF NO BURNS HAVE
OCCURED-USE SOAP & WATER TO CLEANSE SKIN. INHALATION: REMOVE TO
FRESH AIR. ADMINISTER OXYGEN IF BREATHING DIFFICULTY. ADMINISTER
CPR IF CARDIA C ARREST OCCURS. INGESTION: INDUCE VOMITING. GIVE 1
TO 2 GLASSES OF WATER. DON'T ADMINISTER LIQUIDS & INDUCE VOMITING
IF UNCONSCIOUS OR CONVULSION. OBTAIN MEDICAL ATTENTION IN ALL CASES
(SEE SUPP.).
===================== Fire Fighting Measures =====================
Extinguishing Media:CO2, DRY CHEMICAL POWDER OR SPRAY.
Unusual Fire/Explosion Hazard:FLAMMABLE LIQUID
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE AREA. WEAR APPROPRIATE EQUIPMENT.
VENTILATE AREA. SWEEP UP & PLACE IN AN APPROPRIATE CONTAINER. WASH
CONTAMINATED SURFACES TO REMOVE ANY RESIDUES.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP TIGHTLY CLOSED IN A COOL DRY
PLACE. STORE ONLY W/COMPATIBLE CHEMICALS. AVOID CONTACT W/SKIN,
EYES & CLOTHING. DON'T WEAR CONTACT LENSES.
Other Precautions:FOR LABORATORY USE ONLY. DON'T USED AS DRUGS,
COSMETICS, AGRICULTURAL OR PESTICIDAL PRODUCTS, FOOD ADDITIVES OR
AS HOUSEHOLD CHEMICALS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE APPROPRIATE OSHA/MSHA APPROVED SAFETY
EQUIPMENT.
Ventilation:HANDLE ONLY IN A HOOD
Work Hygienic Practices:REMOVE/WASH CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
FIRST AID: IF PATIENT EXHIBITS SHOCK, KEEP WARM & QUIET. ANTIDOTE:
ATROPINE SULFATE. DON'T USE 2-PAM (PRALIDOXIME CHLORIDE). DON'T USE
MORPHINE.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:172-174F
Vapor Pres:5
Vapor Density:1.2946
Solubility in Water:SLIGHT
Appearance and Odor:COLORLESS, CRYSTALLINE SOLID W/PUNGENT ACRID ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
REACTS W/WATER & MOST REACTIVE HYDROGEN COMPOUNDS
Stability Condition to Avoid:LIGHT - DARK COLOR DOESN'T AFFECT PURITY.
MOISTURE, AIR SENSITIVE, SENSITIVE TO HEAT.
Hazardous Decomposition Products:DECOMPOSES UNDER ALKALINE CONDITIONS
==================== Disposal Considerations ====================
Waste Disposal Methods:BURN IN A CHEMICAL INCINERATOR EQUIPPED W/AN
AFTERBURNER & SCRUBBER. DISPOSE OF IN ACCORDANCE W/FEDERAL, STATE,
& LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CHELANT REAGENT #4, 554
CAGE:CHEM1
CAGE:CHEM1
============= Composition/Information on Ingredients =============
Ingred Name:ERIOCHROME BLACK T
CAS:1787-61-7
Fraction by Wt: 2.0%
Ingred Name:METHYL RED SODIUM SALT
CAS:845-10-3
Fraction by Wt: 0.5%
Ingred Name:SODIUM CHLORIDE
CAS:7647-14-5
RTECS #:VZ4725000
Fraction by Wt: 97.5%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL: MAY PRODUCE COUGHING &
IRRIT. SKIN: CONTACT MAY CAUSE IRRITATION & DEFATTING OF SKIN. EYE:
CONTACT MAY CAUSE REDNESS PAIN & IRRITATION. INGESTION: LARGE DOSES
MAY CAUSE NAUSEA, VOMITINGRIGIDITY, CONVULSIONS & PROSTRATION.
DEHYDRATION & CONGESTION OCCUR IN MOST INTERNAL ORGANS. (SEE EFTS
OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: CHRONIC: INHALATION MAY CAUSE MUCOUS
IRRITATION. SKIN CONTACT MAY CAUSE DERMATITIS. PROLONGED EYE
CONTACT MAY CAUSE CONJUNCTIVITIS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:FOR SKIN CONTACT WASH WITH SOAP OR MILD DETERGENT FOR AT
LEAST 15 MINUTES. GET MEDICAL ATTENTION. FOR EYE CONTACT WASH EYES
IMMEDIATELY WITH LARGE AMOUNTS OF WATER FOR AT LEAST 15 MINUTES.
GET IMMEDIA TE MEDICAL ATTENTION. IF INGESTED, IMMEDIATELY GIVE 2-4
GLASSES OF WATER AND INDUCE VOMITING BY TOUCHING FINGER TO BACK OF
THROAT. GET IMMEDIATE MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT. .
Unusual Fire/Explosion Hazard:WHEN HEATED TO DECOMPOSITION MAY EMIT
MINOR AMOUNTS OF TOXIC SO*X AND NO*X FUMES.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB OR SCRAPE UP, VACUUM.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTACT WITH SKIN AND EYES.
AVOID BREATHING DUST. DO NOT INGEST.
Other Precautions:OBSERVE CAUTION IN HANDLING AND STORAGE OF CHEMICALS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED MECHANICAL RESPIRATOR DURING
NORMAL USE AND FOR GASES, VAPORS, DUST, FUMES EXCEEDING TLV.
Ventilation:GENERAL VENTILATION OR LOCAL EXHAUST.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:2575F,1413C
Vapor Pres:1 @ 865 C
Spec Gravity:2.15
pH:5.9
Solubility in Water:36%
Appearance and Odor:DARK PURPLE CRYSTALLINE MATERIAL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
BROMINE TRIFLUORIDE, MANY METALS AND BUILDING MATERIALS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:WHEN HEATED TO DECOMPOSITION MAY EMIT
MINOR AMOUNTS OF TOXIC SO*X AND NO*X FUMES.
==================== Disposal Considerations ====================
Waste Disposal Methods:OBSERVE GOVERNMENTAL SPILL AND WATER QUALITY
REGULATIONS. DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL REGS. .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:USA 410
CAGE:JO533
CAGE:0AZS7
CAGE:JO533
============= Composition/Information on Ingredients =============
Ingred Name:IRON
CAS:7439-89-6
RTECS #:NO4565500
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:NICKEL (SARA 313) (CERCLA) (MFR'S CAS #7440-02-2)
CAS:7440-02-0
RTECS #:QR5950000
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3
Ingred Name:MOLYBDENUM
CAS:7439-98-7
RTECS #:QA4680000
OSHA PEL:10 PPM
ACGIH TLV:10 PPM
Ingred Name:MANGANESE (SARA 313)
CAS:7439-96-5
RTECS #:OO9275000
OSHA PEL:5 MG/M3 DUST, C
ACGIH TLV:5 MG/M3 DUST
Ingred Name:CHROMIUM (SARA 313) (CERCLA)
CAS:7440-47-3
RTECS #:GB4200000
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SILICON
CAS:7440-21-3
RTECS #:VW0400000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:NIOBIUM; (COLUMBIUM)
CAS:7440-03-1
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:CALCIUM CARBONATE
CAS:1317-65-3
RTECS #:EV9580000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:CALCIUM FLUORIDE
CAS:7789-75-5
RTECS #:EW1760000
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SODIUM SILICATE
CAS:1344-09-8
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CLAY (KAOLIN); (ALUMINUM SILICATES)
CAS:1332-58-7
RTECS #:GF1670500
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:2 MG/M3 TDUST
Ingred Name:POTASSIUM SILICATES
CAS:1312-76-1
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CRYOLITE
CAS:15096-52-3
RTECS #:WA9625000
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ZIRCONIUM SILICATES
CAS:7440-42-6
RTECS #:9999999ZZ
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:COPPER (SARA 313) (CERCLA)
CAS:7440-50-8
RTECS #:GL5325000
OSHA PEL:0.1MG/M3 FUME;1 DUST
ACGIH TLV:0.2 MG/M3 FUME
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:SILICA, CRYSTALLINE - QUARTZ; (QUARTZ)
CAS:14808-60-7
RTECS #:VV7330000
OSHA PEL:N/K
ACGIH TLV:0.1 MG/M3 RDUST
Ingred Name:SUPDAT: BE REACHED BEFORE LIM OF 5 MG/M3 FOR GEN WELDING
FUMES IS REACHED. WATCH CR(VI) LEVEL. GASEOUS RXN PRODS(ING 19)
RTECS #:9999999ZZ
Ingred Name:ING 18:MAY INCL CO & CO*2. OZONE & NITROGEN OXIDES MAY BE
FORMED BY RADIA FROM ARC. CONTACT NEHC FOR MORE INFO .
RTECS #:9999999ZZ
Ingred Name:EXPLAN OF CARCIN:CRYSTALLINE-QUARTZ:IARC MONO, V 68,
1997:GRP 1. NTP 7TH ANNUAL RPT ON CARCINS, 1994:ANTIC TO BE CARCIN.
RTECS #:9999999ZZ
Ingred Name:EFTS OF OVEREXP: IN LUNG) & IS BELIEVED TO AFFECT PULM
FUNC. REPETITIVE EXPOS TO FLUORIDE FUMES &/OR GASES MAY (ING 22)
RTECS #:9999999ZZ
Ingred Name:ING 21: CAUSE EXCESS CALCIFICATION OF BONES & LIGAMENTS OF
RIBS, PELVIS & SPINAL COLUMN. CHROMIUM(VI) CMPDS MAY (ING 23)
RTECS #:9999999ZZ
Ingred Name:ING 22:CAUSE ULCERATION & PERFORATION OF NASAL SEPTUM &
LIVER & KIDNEY DMG. REPETITIVE OVEREXP TO NICKEL OXIDES (ING 24)
RTECS #:9999999ZZ
Ingred Name:ING 23: MAY LEAD TO LUNG FIBROSIS OR PNEUMOCONIOSIS. ARC
RAYS CAN INJURE EYES & BURN SKIN. ELEC SHOCK CAN KILL.
RTECS #:9999999ZZ
Ingred Name:EYE PROT:& FULL LNGTH FSHLD W/FILTER LENS SHADE
#12-14/DARKER. SHIELD OTHERS BY PROVIDING SCREENS & FLASH GOGGS.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE OVEREXP TO WELDING FUMES MAY
RSLT IN DISCOMFORT SUCH AS DIZZ, NAUS OR DRYNESS/IRRIT OF NOSE,
THROAT/EYES. INHAL OF EXTREMELY HIGH LEVELS OF FLUORIDES MAY CAUSE
ABDOM PAIN, DIARR, MUSC WEAK & CON VLS. CONTINUED INHAL COULD CAUSE
UNCON & DEATH. CHROMIUM (VI) CMPDS PRESENT IN FUME MAY CAUSE SEV
IRRIT(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NICKEL: IARC MONO, VOL 49, PG 257,
1990:GRP 2B. NTP 7TH ANNUAL RPT ON CARCINS, 1994:ANTIC TO BE
CARCIN. SILICA, (ING 20)
Effects of Overexposure:HLTH HAZ: OF BRONCH TUBES & LUNGS. INGEST OF
CHROMIUM (VI) SALTS MAY CAUSE INJURY/DEATH. CHROMIUM(VI) CMPDS MAY
BURN EYES. CHROMIUM CMPDS MAY CAUSE ALLERGIC RXNS. NICKEL OXIDES IN
FUME MAY CAUSE TIGHT NESS AROUND CHEST, FEVER & ALLERGIC RXNS.
CHRONIC OVEREXP TO WELDING FUMES CAN LEAD TO SIDEROSIS (IRON
DEPOSITS (ING 21)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST: CALL MD IMMED . EYES: IMMED FLUSH W/POTABLE WATER FOR
A MINIMUM OF 15 MINUTES, SEEK ASSISTANCE FROM MD . SKIN: FLUSH
W/COPIOUS AMTS OF WATER. CALL MD . CALL FOR MED ASSISTANC E. USE
FIRST AID PROCEDURERS RECOM BY AMERICAN RED CROSS. IF BREATHING IS
DFCLT, GIVE OXYGEN. IF NOT BREATHING USE CPR. CONSULT MD IF
IRRITATION OF EYES & SKIN OR FLASH BURNS DEVELOP AFTER EXPOSURE.
===================== Fire Fighting Measures =====================
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NON-FLAMMABLE: WELDING ARC AND SPARKS CAN
IGNITE COMBUSTIBLES. SEE Z-49.1 SAFETY IN WELDING & CUTTING,
PUBLISHED BY AWS, 550 NW LEJEUNE RD, MIAMI, FL 33126.
================== Accidental Release Measures ==================
Spill Release Procedures:NONE SPECIFIED BY MANUFACTURER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:READ & UNDERSTAND MFR'S INSTRUCTIONS &
PREC LABEL ON PROD. ADVISE WELDERS TO KEEP THEIR HEAD OUT OF FUMES.
SEE ANSI Z49.1 & 29 CFR 1910 FOR MORE INFO.
Other Precautions:ONE METHOD OF DETERMINING COMPOSITION & QTY OF FUMES
& GASES TO WHICH WORKERS ARE EXPOSED IS TO TAKE AIR SAMPLE FROM
INSIDE WELDER'S HELMET WHILE WORN OR IN WORKER'S BREATHING ZONE.
SEE ANSI/AWS F1.1 AVAIL FROM AMERICAN WELDING SOCIETY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED RESPIRABLE FUME RESPIRATOR OR
AIR SUPPLIED RESPIRATOR WHEN WELDING IN CONFINED SPACE OR GENERAL
WORK AREA WHERE LOCAL EXHAUST AND/OR VENTILATION DOES NOT KEEP
EXPOSURE BELOW THE THR ESHOLD LIMIT VALUE.
Ventilation:USE PLENTY OF VENT &/OR LOC EXHST AT ARC TO KEEP FUMES &
GASES BELOW TLV W/IN WORKER'S BRTHG ZONE & GEN WORK AREA.
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER . ARM
PROTECTORS, APRON, HATS, SHOULDER PROT & DARK SUBSTANTIAL CLTHG.
Work Hygienic Practices:TRAIN WELDER NOT TO ALLOW ELEC LIVE PARTS TO
GROUND.
Supplemental Safety and Health
HAZ DECOMP PRODS: WELDED, PROCS FOLLOWED & ELECTRODES USED. REASONABLE
EXPECTED FUME CONSTITUENTS OF PROD WOULD INCL: COMPLEX OXIDES OF
ALUMINUM, IRON, MANGANESE, SILICON, TITANIUM, CHROMIUM, NICKEL,
CALCIUM, COLUMBIAN, MOLYBDENUM & COPPER. FLUORIDES WILL ASLO BE
PRESENT. FUME LIM FOR (CR(VI)(0.05 MG/M3) MAY (ING 18)
================== Physical/Chemical Properties ==================
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:WELDING FUMES & GASES CANNOT BE
CLASSIFIED SIMPLY. COMPOSITION & QTY OF FUMES & GASES DEPEND ON
METAL BEING (SUPDAT)
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCARD ANY PRODUCT, RESIDUE, DISPOSAL CONTAINER
OR LINER IN AN ENVIRONMENTALLY ACCEPTABLE MANNER APPROVED BY
FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:NEW SALEM MAPLE STAIN
CAGE:GEMIN
CAGE:GEMIN
============= Composition/Information on Ingredients =============
Ingred Name:2-BUTOXYETHANOL (ETHYLENEGLYCOL MONOBUTYL ETHER), BUTYL
CELLOSOLVE, BUTYL GLYCOL, GLYCOL ETHER EB
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: 39.07%
Other REC Limits:25 PPM (SKIN)
OSHA PEL:50 PPM (SKIN)
ACGIH TLV:25 PPM (SKIN)
Ingred Name:TOLUENE
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 13.60%
Other REC Limits:375 MG/CUM
ACGIH TLV:100 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ISOPROPANOL (ISOPROPYL ALCOHOL), 2-PROPANOL, DIMETHYL
CARBINOL
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 4.91%
Other REC Limits:400 PPM
OSHA PEL:400 PPM
ACGIH TLV:400 PPM
Ingred Name:ISOBUTYL ACETATE, ESTER
CAS:110-19-0
RTECS #:AI4025000
Fraction by Wt: 3.30%
Other REC Limits:150 PPM
OSHA PEL:150 PPM
ACGIH TLV:713 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:LIGHT ALIPHATIC NAPHTHA, VM & P NAPHTHA, LACOLENE*93/4*
CAS:64742-89-8
Fraction by Wt: 23.70%
OSHA PEL:300 PPM
ACGIH TLV:300 PPM
RTECS #:9999999WG
Fraction by Wt: 7.5%
RTECS #:9999999VO
Fraction by Wt: 6.608%
Ingred Name:WET NITROCELLULOSE, NITROCELLULOSE, NITRATE CELLULOSE
CAS:9004-70-0
RTECS #:QW0975200
Fraction by Wt: 2.66%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: RESPIRATORY & NASAL
IRRITATION & ASPHYXIATION. SKIN: IRRITATION/DERMATITIS. EYES:
IRRITATION.INGESTION: GASTROINTESTINAL IRRITATION. LONG TERM OF
OVEREXPOSE OF SOLVENT IS SUSPECTED OF CAUS ING LIVER, KIDNEY, LUNG
& CNS DAMAGE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INGESTION: VOMITING, NAUSEA, DIARRHEA.
INHALATION: DIZZINESS, WEAKNESS, FATIGUE, NAUSEA, HEADACHE,
POSSIBLE UNCONSCIOUSNESS. EYES: REDNESS, TEARING, BLURRED VISION,
SKIN: REDNESS, DRYNESS, RASH, CRACK S.
Medical Cond Aggravated by Exposure:RESPIRATORY & SKIN SENSITIVITY.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. AID BREATHING. EYES:FLUSH
IMMEDIATLY W/LARGE AMOUNTS OF WATER FOR 15 MINUTES. SKIN: REMOVE
CONTAMINATED CLOTHING, WASH W/SOAP & WATER. INGESTION: DRINK 1 OR 2
GLASSES OF WATER TO DILUTE. DON'T INDUCE VOMITING. OBTAIN MEDICAL
ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:40.0 F
Lower Limits:.9%
Upper Limits:12.1%
Extinguishing Media:ALCOHOL FOAM, CO2, DRY CHEMICAL
Fire Fighting Procedures:USE NIOSH APPROVED FULL FACE, SCBA, WATER MAY
BE INEFFECTIVE. IF WATER IS USED, FOG NOZZLES ARE PREFERABLE.
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR & MAY TRAVEL
ALONG GROUND/MAY BE MOVED BY VENTILATION & IGNITED BY IGNITION
SOURCES DISTANT FROM & OTHER IGNITION SOURCES.
================== Accidental Release Measures ==================
Spill Release Procedures:SOAK UP SPILLS W/INERT MATERIAL, SCRAPE UP
W/NONSPARKING TOOLS. PUT IN COVERED METAL CONTAINER FOR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN TIGHTLY CLOSED CONTAINERS.
KEEP AWAY FROM SPARKS/EXCESSIVE HEAT/OPEN FLAMES. TRANSFER BETWEEN
CONTAINERS THAT HAVE BEEN ELECTRICALLY GROUNDED
Other Precautions:DO NOT TAKE INTERNALLY, CAN NOT BE MADE NONPOISONOUS.
AVOID INHALATION/SKIN CONTACT. RELEASE PRESSURE ON CONTAINER
SLOWLY. STORE & USE IN WELL VENTILATED AREAS. DON'T DRAG, SLIDE,
PUNCTURE, OR REUSE C ONTAINERS. DON'T USE PRESSURE TO EMPTY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NESA/NIOSH APPROVED RESPIRATOR. COMBINATION
DUST/VAPOR RESPIRATOR, OR CHEMICAL RESPIRATOR.
Ventilation:LOCAL EXHAUST TO MAINTAIN WORK SPACE BELOW TLV.
Other Protective Equipment:EYEWASH STATION/EMERGENCY SHOWER/AUTO-WATER
SPRAY.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH THROUGHLY AFTER HANDLING. SMOKE IN DESIGNATED AREAS
ONLY.
Supplemental Safety and Health
NEVER USE WELDING/CUTTING TORCH ON/NEAR DRUMS BECAUSE PRODUCT CAN
IGNITE EXPLOSIVELY. INTENTIONAL MISUSE BY DELIBERATELY,
CONCENTRATED & INHALING SOLVENTS MAY BE HARMFUL/FATAL. DON'T SPRAY
LACQUER PRO DUCTS IN THE SAME SPRAY BOOTH W/OXIDIZING STAINS,
GLAZES, OR VARNISHES.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:177.4-342.5
Vapor Pres:32.80
Vapor Density:> THAN AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:90.98
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG ALKALINES, STRONG MINERAL ACIDS.
Stability Condition to Avoid:HIGH HEAT, SPARKS, FLAMES.
Hazardous Decomposition Products:OXIDES OF CARBON & NITROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE W/LOCAL, STATE,
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SKD-NF/ZP-9B DEVELOPER (OLD FORMULATION)
Kit Part:Y
Preparer's Name:BRUCE C. GRAHAM
CAGE:37676
CAGE:37676
============= Composition/Information on Ingredients =============
Ingred Name:METHYL CHLOROFORM (1,1,1-TRICHLOROEHANE) (SARA III)
CAS:71-55-6
RTECS #:KJ2975000
Fraction by Wt: 65.0%
OSHA PEL:350 PPM/450 STEL
ACGIH TLV:350 PPM/450STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ozone Depleting Chemical:1
Ingred Name:CHLORODIFLUOROMETHANE
CAS:75-45-6
RTECS #:PA6390000
Fraction by Wt: 25.0%
OSHA PEL:1000 PPM
ACGIH TLV:1000PPM; 9192
Ozone Depleting Chemical:2
Ingred Name:1,4-DIOXANE (DIETHYLENE DIOXIDE) (SARA III)
CAS:123-91-1
RTECS #:JG8225000
Fraction by Wt: 02.0%
OSHA PEL:S, 100 PPM
ACGIH TLV:S, 25 PPM; 9293
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:IRRITATES EYES BY SOLVENT ACTION.
Explanation of Carcinogenicity:1,1,1-TRICHLOROETHANE AND 1,4-DIOXANE
ARE CURRENTLY UNDER TEST TO DETERMINE THE POSSIBLE
CARCINOGENICITY,PER MFR.
Effects of Overexposure:INHALATION:CAUSES
DIZZINESS,DROWSINESS,NAUSEA.CAUSES UNCONSCIOUSNESS AT HIGH
EXPOSURE; SKIN:NOT ABSORBED THROUGH SKIN IN SIGNIFICANT
AMOUNTS.HOWEVER,IRRITATES BY DISSOLVING SKIN OILS; EYES:IRRITATING
DUE TO STRONG SOLVENT ACTION; INGESTION:LOW SINGLE DOSE TOXICITY IN
TEST ANIMALS.
Medical Cond Aggravated by Exposure:NONE KNOWN TO MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION:REMOVE TO FRESH AIR.IF NOT BREATHING,GIVE CPR.IF
BREATHING IS DIFFICULT,GIVE OXYGEN; SKIN:WASH OFF IN FLOWING WATER
OR SHOWER.RMV CONTAMINATED CLOTHING AND WASH BEFORE REUSE.USE
SOOTHING LO TION; EYES:FLUSH EYES WITH A STEADY,GENTLE FLOW OF
WATER.GET MEDICAL ASST; INGESTION:DO NOT INDUCE VOMITING.IF VOMIT
IS INHALED,IT MAY CAUSE ASPHYXIATION.GET MED ATTN IMMEDIATELY;IN
EMERGENCY CALL MD
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:CARBON DIOXIDE,FOAM
Fire Fighting Procedures:KEEP CONTAINERS COOL WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:AEROSOL CANS CAN BURST IF HEATED ABOVE
130F(54.4C)
================== Accidental Release Measures ==================
Spill Release Procedures:LESS THAN ONE QUART:WIPE UP BUT DO NOT BREATHE
VAPORS;ONE QUART OR MORE:WEAR ALL PERSONAL SAFETY EQUIPMENT TO
AVOID VAPOR/LIQ CONTACT OR BREATHING.EVACUATE UNPROTECTED
PERSONS.ELIMINATE IGN SOURCES.DI KE LIQ.PLACE IN COVERED DRUMS.SEND
TO RECLAIMER.
Neutralizing Agent:NOT NOTED BY MFR.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM HEAT SOURCES TO
MINIMIZE THE DANGER FROM EXPOSURE TO FIRES.STORE IN
DRY,COOL,VENTILATED AREA.
Other Precautions:DO NOT USE AROUND FLAMES/RED HOT SURFACES.DO NOT HEAT
ABOVE 130F.AVOID BREATHING VAPORS.AVOID FREQUENT/PROLONGED EXPOSURE
TO SKIN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IN POORLY VENTILATED AREAS,WEAR A RESPIRATOR
WITH CHEMICAL CARTRIDGE.IN CONFINED OR UNVENTILATED SPACES,WEAR A
FULL MASK WITH SEPARATE AIR SUPPLY.
Ventilation:GENERAL VENTILATION TO KEEP BELOW LIMITS OF TLV.
Work Hygienic Practices:WASH HANDS THOROUGHLY WITH SOAP & WATER AFTER
HANDLING/USE OF:SKD-NF/ZP-9B DEVELOPER.
Supplemental Safety and Health
NSN FOR A KIT OF 3 PARTS.PER MIL-I-25135D,TYPE II,METHOD C AND
QPL-25135-15,THE PARTS ARE:PENETRANT(SKL-HF/S OR
SKL-LO),DEVELOPER(SKD-NF/ZP-9B ONLY),&
CLEANER/REMOVER(SKC-NF/ZC-7B);REFERENCE:DGSC-SLM CASE HISTORY
#88281H FOR DETAILS;KEY1:J7;THIS ENTRY
DESCRIBES:DEVELOPER(SKD-NF/ZP-9B);SKD-S NOT QUALIFIED FOR NSN.
================== Physical/Chemical Properties ==================
HCC:V2
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:N/R(AEROSOL
Spec Gravity:1.3 (OF LIQUID)
Evaporation Rate & Reference:3.0 (ETHYL ALCOHOL=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:WHITE MOBILE LIQUID BEFORE FILLING IN AEROSOL CANS.
Percent Volatiles by Volume:100%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
POWDERED ZINC & POWDERED ALUMINUM
Stability Condition to Avoid:HEAT/HIGH TEMPERATURES
Hazardous Decomposition Products:PHOSGENE,HYDROCHLORIC ACID GAS &
OXIDES OF CARBON.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF AS EPA HAZARDOUS WASTE #F002;MAY BE
SENT TO SOLVENT RECLAIMER.INSURE THAT AEROSOL CANS ARE EMPTY AND
DEPRESSURIZED BEFORE DISCARDING,UNLESS A WASTE TREATMENT FACILITY
IS APPROVED TO ACCEPT THEM AS IS.COMPLY WITH FED,ST,& LOCAL REGS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:R7 K 69 POLANE REDUCER
CAGE:54636
CAGE:54636
============= Composition/Information on Ingredients =============
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 15%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:200 PPM; Z-2
ACGIH TLV:S, 50 PPM; 9394
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ETHYL BENZENE (SARA III)
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: <5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/125STEL;9394
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 60%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/150STEL;9394
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:METHYL ISOBUTYL KETONE (HEXONE) (SARA III)
CAS:108-10-1
RTECS #:SA9275000
Fraction by Wt: 25%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:50 PPM/75 STEL; 9394
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:VOLATILE ORGANIC COMPOUNDS, 7.04 LB, 843G (THEORETICAL).
RTECS #:9999999VO
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:OVEREXPOSURE CAUSES
EYE/SKIN/RESP IRRIT.MAY CAUSE CNS DEPRES.EXTREME OVEREXPOSURE MAY
RESULT IN UNCONSC & POSSIBLE DEATH.CHRONIC:PROLONG OVEREXPOSURE TO
INGREDS MAY CAUSE ADVERSE EFFECTS TO LIVE R/URINARY/BLOOD
FORMING/CARDIO-VASCULAR/REPRODUCTIVE SYS.REPORTS ASSOC REP/PROL
EXPOS TO SOLVENT W/PERM BRAIN & CNS DAMA
Explanation of Carcinogenicity:PER MSDS NO INGREDIENT IN PRODUCT IS
IARC/NTP/OSHA LISTED CARCINOGEN.
Effects of Overexposure:CNS DEPRESSION ACCOMPANIED BY HEADACHE, DIZZ,
NAUSEA, CONFUSION, STAGGERING GAIT. UNCONSC, DEATH. PERM BRAIN &
NERVOUS SYS DAMAGE.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MFG.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE FROM EXPOUSRE.RESTORE BREATHING.KEEP WARM/QUIET.
SKIN:WASH THOROUGHLY W/SOAP & WATER.REMOVE CONTAMIN CLOTHING.
EYE:FLUSH W/LG AMTS OF WATER FOR 15MINS.GET MED ATTN. INGEST:NEVER
GIVE ANYT HING BY MOUTH TO UNCONSC PERSON.DO NOT INDUCE
VOMITING.GIVE SEVERAL GLASSES OF WATER.SEEK MED ATTN.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:35.0F,1.7C
Lower Limits:1.0
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:FULL PROTECTIVE EQPMT INCLUDING SCBA SHOULD BE
USED.WATER SPRAY MAY BE INEFFECTIVE.FOG NOZ PREFERABLE IF USE
WATER.COOL CNTNRS W/WATER TO PREVENT PRESS BUILDUP.
Unusual Fire/Explosion Hazard:ISOLATE FROM HEAT/ELEC EQPMT/SPARK/OPEN
FLAME.CLSD CNTNRS EXPOSED TO EXTREME HEAT CAN EXPLODE.APPLY TO HOT
SURFACES W/SPEICAL PRECAUTIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE W/INERT ABSORBENT.
Neutralizing Agent:NOT APPLICABLE.
======================Handling and Storage ======================
Handling and Storage Precautions:CONTENTS FLAMM.KEEP AWAY FROM
HEAT/SPARKS/OPEN FLAMES.DURING USE & TIL VAPORS AFE GONE KEEP AREA
VENTILATED,DO NOT SMOKE,EXTINGUISH ALL IGN SOURCES.
Other Precautions:CONSULT NFPA CODE.USE APPROVED BONDING & GROUNDING
PROCEDURES.KEEP CNTNR CLOSED WHEN NOT IN USE.TRANSFER ONLY TO
APPROVED CNTNRS W/COMPLETE & APPROPRIATE LABELING.DO NOT TAKE
INTERNALLY.KEEP OUT OF RE ACH OF CHILDREN.DOT STORAGE CATEGORY-IB.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF PERSONAL EXPOUSRE CANNOT BE CONTROLLED BELOW
APPLICABLE LIMITS BY VENTILATION, WEAR RESP DEVICE APPROVED BY
NIOSH/MSHA FOR PROTECTION AGAINST INGREDIENTS.
Ventilation:LOCALEXHAUST PREFERABLE. GEN EXHAUST ACCEPTABLE IF EXPOSURE
TO INGREDS MAINTAINED BELOW APPLICALBE EXPOSURE LIMITS.
Other Protective Equipment:NONE SPECIFIED BY MFG.WASH CONTAMINATED
CLOTHING PRIOR TO REUSE.
Work Hygienic Practices:USE ONLY W/ADEQUATE VENITLATION.AVOID BREATHING
VAPOR/SPRAY MIST/CONTACT W/SKIN/EYES.WASH HANDS AFTER HANDLING.
Supplemental Safety and Health
REFER TO OSHA STDS 1910.94;1910.107; 1910.108 FOR VENTILATION.
INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING & INHALING
CONTENTS CAN BE HARMFUL/FATAL.
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:222F,106C
Vapor Density:>AIR.
Evaporation Rate & Reference:SLOWER THAN ETHER.
Appearance and Odor:PER TIR SOLVENT SOLUTION FOR PAINT.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MFG.
Stability Condition to Avoid:EXTREME HEAT, OPEN FLAMES, ELECTRICAL
EQPMT, SPARKS.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE FROM PRODUCT MAY BE HAZ AS DEFINED UNDER
RCRA 40CFR261.WASTE MUST BE TESTED FOR IGNITABILITY TO DETERMINE
APPLICALBE EPA HAZ WASTE NOS.INCINERATE IN APPROVED FACILITY.DO NOT
INCINERATE CLOSED CN TNR.DISPOSE OF IAW FED/STATE/LOC POLLUTION
REGS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SNAP BRAKE CLEANER
CAGE:74438
CAGE:74438
============= Composition/Information on Ingredients =============
Ingred Name:NO INGREDIENT FOR THIS FORMULATION_INGREDIENT
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CHLOROCARBON MATLS HAVE PRDCED SENSIT
OF MYOCARDIUM TO EPINEPHRINE IN LAB ANIMALS & COULD HAVE A SIMILAR
EFT IN HUMANS. ADRENOMIMETICS (E.G. EPINEPHRINE) MAY BE
CONTRAINDICATED EXCEPT FOR LIFE-SUSTAIN ING USES IN HUMANS
ACUTELY/CHRONICALLY EXPOS TO CHLOROCARBONS . INHAL:MAY CAUSE DROW,
IRRIT, & @ (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:HIGH LEVS IS BLOOD PRESS DEPRESSANT,
CARD SENSITIZER, & VENTRICULAR ARRHYTHMIN. NOTE:TARGET ORGANS LIVER
& HEART. NOTE:ADRENALINE TYPE DRUGS SHOULD NOT BE GIVEN TO OVEREXP
VICTIM. EYE:MAY CAU SE IRRIT AND/OR CORNEAL INJURY. SKIN:MAY CAUSE
IRRIT. INGEST:PROD HAS LOW ORAL TOX, IF INGEST, BEWARE OF CHEM
PNEUMONIA.
Medical Cond Aggravated by Exposure:ACUTE & CHRONIC LIVER DISEASES &
RHYTHM DISORDERS OF THE HEART.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR, ADMINISTER CPR IF NEC, CALL PHYS.
INGEST:DO NOT INDUCE VOMIT, CALL PHYS. SKIN:REMOVE CONTAMINATED
CLOTHING, WASH W/SOAP & WATER. EYES:FLUSH W/LARGE QUANTITIES OF
WATER FOR A T LEAST 15 MINUTES, CALL PHYS.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:7.5%
Upper Limits:15%
Extinguishing Media:WATER FOG, STANDARD FOAM, CARBON DIOXIDE.
Fire Fighting Procedures:NIOSH/MSHA APPRVD PRESS DEMAND SCBA & FULL
PROT EQUIP . KEEP CNTNRS COOL. USE EQUIP/SHIELDING TO PROT PERS
AGAINST BURSTING, RUPTURING, VENTING CNTNRS.
Unusual Fire/Explosion Hazard:THERMAL DECOMPOSITION PRODUCTS MAY
INCLUDE HCL & PHOSGENE . AT ELEVATED TEMPERATURES (OVER 130F)
CONTAINERS MAY VENT RUPTURE OR BURST.
================== Accidental Release Measures ==================
Spill Release Procedures:AVOID BREATHING VAPORS, AVOID SKIN CONT WITH
LIQUID.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE WHERE TEMPERATURES COULD
EXCEED 54C/130F.
Other Precautions:NO SMOKING IN AREA OF USE. DO NOT USE IN GEN VICINITY
OF ARC WELDING, OPEN FLAMES OR HOT SURFACES. HEAT &/OR UV RADIA MAY
CAUSE FORMATION OF HCL &/OR PHOSGENE .
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT APPLICABLE IN NORMAL USE. NIOSH/MSHA
APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:LOC EXHAUST (HOODS, FANS, ETC.) SHOULD BE SUFFICIENT TO
REMOVE SOLV & PROPELLANT VAP. MECH (GEN AREA VENT) (SUPDAT)
Other Protective Equipment:DO NOT WEAR CLOTHING SOAKED BY SPRAY.
Work Hygienic Practices:PRACTICE GOOD PERSONAL HYGIENE.
Supplemental Safety and Health
VENT:SHOULD BE ON WHILE SPRAYING TO REMOVE SOLVENT VAPOR.
================== Physical/Chemical Properties ==================
Vapor Pres:125 PSIG
Vapor Density:HVR/AIR
Spec Gravity:1.3 (WATER=1)
Evaporation Rate & Reference:>1.0 (N BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:COARSE WHITE SPRAY WITH CHLORINATED ODOR (LEAVES NO
RESIDUE).
Percent Volatiles by Volume:90+
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACTIVE METALS, STRONG ALKALINES, AND STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:HCL & PHOSGENE . FROM BURNING,
WELDING, OXIDATION, HIGH TEMP-HYDROGEN CHLORIDE, CHLORINE,
PHOSGENE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH FEDERAL,
STATE, AND LOCAL REGULATIONS . DO NOT PUNCTURE/INCIN CNTNRS. GIVE
EMPTY, LEAKING OR FULL CNTNRS TO DISP SERVICE EQUIPPED TO SAFELY
HANDLE & DISPOSE O F PRESSURIZED CNTNRS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SALT, SODIUM CHLORIDE NACL
Preparer's Name:RONALD F. SWEET SR.
CAGE:0YBP2
CAGE:0YBP2
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM CHLORIDE (NACL - MOLECULAR WEIGHT 58.4428) PH 20%
SOLUTION 6.5-9.5 MATERIAL NORMALLY SOLID.
CAS:7647-14-5
RTECS #:VZ4725000
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NA
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION MAY CAUSE MILD IRRITATION
OF NOSE & THROAT. SKIN/EYE: DUST MAY CAUSE MILD IRRITATION.
INGESTION OF LARGE AMOUNTS >0.1 LB MAY CAUSE GASTROINTESTINAL
UPSET.
Effects of Overexposure:MILD IRRITATION TO NOSE, THROAT, SKIN, EYES.
======================= First Aid Measures =======================
First Aid:SKIN: WASH W/WATER. EYES: IRRIGATE W/PLENTY OF WATER.
===================== Fire Fighting Measures =====================
Flash Point:NOT FLAMMABLE
Lower Limits:NA
Upper Limits:NA
Extinguishing Media:NA
Fire Fighting Procedures:NA
Unusual Fire/Explosion Hazard:NA
================== Accidental Release Measures ==================
Spill Release Procedures:SHOVEL UP DRY MATERIAL INTO EMPTY CONTAINER.
======================Handling and Storage ======================
Handling and Storage Precautions:NORMAL HANDLING. AVOID EYE CONTACT OR
PROLONGED SKIN CONTACT. WET OR DAMP CONDITIONS CAN CAUSE
CAKING/CORROSION OF METAL CONTACT SURFACES.
Other Precautions:STORE IN COOL, DRY AREA. NO SPECIAL CAUTION OR
LABELING ARE REQUIRED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHEN REQUIRED, USE A RESPIRATOR APPROVED BY
NIOSH FOR PRODUCT DUSTS.
Ventilation:LOCAL EXHAUST IF DUSTY CONDITIONS PREVAIL
Other Protective Equipment:WEAR LONG SLEEVED SHIRTS & TROUSERS FOR
ROUTINE PRODUCT HANDLING.
Work Hygienic Practices:NORMAL PRACTICES OF WASHING W/SOAP & WATER.
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:2669F,1465C
Melt/Freeze Pt:M.P/F.P Text:1472F,800C
Vapor Pres:2.4 @746.9
Vapor Density:NA
Spec Gravity:2.16
Evaporation Rate & Reference:NA
Solubility in Water:26.395 MAX @60F
Appearance and Odor:WHITE CRYSTALINE SOLID, SLIGHT SALINE ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE PROVIDED THE PRODUCT IS DRY
Stability Condition to Avoid:WET, DAMP CONDITIONS CAN CAUSE CAKING &
CORROSION.
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:FLUSH RESIDUE W/WATER DOWN LOCAL SEWER IF
PERMITTED BY APPLICABLE DISPOSAL REGULATIONS. NOT A HAZARDOUS
WASTE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:BENZENE
Preparer's Name:C.A. EISENHARD
CAGE:63415
CAGE:60777
CAGE:63415
============= Composition/Information on Ingredients =============
Ingred Name:BENZENE (SARA III)
CAS:71-43-2
RTECS #:CY1400000
Fraction by Wt: 99%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:SEE 1910.1028
ACGIH TLV:10 PPM; A2; 9394
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:NON-AROMATICS
Fraction by Wt: 0.15%
Other REC Limits:NONE RECOMMENDED
Ingred Name:THIOPHENE
CAS:110-02-1
RTECS #:XM7350000
Fraction by Wt: 1% PPM
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:CNS & BONE MARROW DEPRES. MAY AFFECT
IMMUNE SYS & HEART. LOC EFFECTS:RESP IRRIT,PULM EDEMA,DEATH BY
ASPHYXIA,CARDIAC OR RESP FAILURE. SKIN:ERYTHEMA,EDEMA. EYE:IRRIT.
INGEST:LOC IRRIT,BURNING SENSATIONIN
MOUTH/THROAT/STOMACH,HEMORR,INFLAMMLESIONS OF MUC MEM. DEATH FROM
10-15ML. RENAL CONGESTION,VERTIGO,IMPOTENCE.
Explanation of Carcinogenicity:CONTAINS BENZENE [71-43-2] WHICH IS
LISTED BY NTP AND IARC AND REGULATED BY OSHA AS A CARCINOGEN
(CAUSES LEUKEMIA.)
Effects of Overexposure:HEADACHE,DIZZ,WEAKNESS. VESICULATION FISSURING.
DEFATS SKIN, SCALING, DRYNESS, BLISTERING, BURNING SENSATION, DERM
W/ ERYTHEMA. INHAL:BRONCHITIS, PNEUMONIA.
Medical Cond Aggravated by Exposure:PERSONS W/CERTAIN IMMUNOLOGICAL
TENDENCIES, POOR NUTRITION, ANEMIA, DRUG OR CHEMICALLY INDUCED
AGRANULOCYTEMIA.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH W/WATER OR NORMAL SALINE, 15 MIN, HOLD LIDS OPEN.
SKIN: WASH WITH SOAP & WATER. REMOVE CONTAMINATED CLOTHING AND
LAUNDER BEFORE REUSE. INHALATION: REMOVE TO FRESH AIR. AID/RESTORE
BREATHING IF NECESSARY. INGESTED: DO NOT INDUCE VOMITING. PREVENT
ASPIRATION. GET IMMEDIATE MEDICAL CARE.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:12F,-11C
Autoignition Temp:Autoignition Temp Text:1044F
Lower Limits:1.2
Upper Limits:7.8
Extinguishing Media:USE WATER SPRAY, CARBON DIOXIDE, REGULAR FOAM, OR
DRY CHEMICAL.
Fire Fighting Procedures:MOVE CONTAINERS FROM AREA IF W/O RISK. COOL
CONTAINER W/WATER. STAY AWAY FROM ENDS OF TANKS. FOR MASSIVE
FIRE,USE UNMANNED HOSE HOLDERS OR WITHDRAW AND LET BURN
Unusual Fire/Explosion Hazard:WITHDRAW IMMEDIATELY IF CONTAINER IS
VENTING, OR DISCOLORED. USE WATER IN FLOODING AMOUNTS AS A FOG.
STREAM MAY SPREAD FIRE. AVOID BREATHING HAZARDOUS MATERIAL.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE IGN SOURCES.STOP LEAK SAFELY.REDUCE
VAPORS W/H2O SPRAY.TAKEUP W/SAND,ABSORBENT MATL.PLACE INTO
CONTAINERS FOR DISPOSAL.LG:DIKE.SOIL:DIKE.USE CEMENT
POWDER,FLYASH,COMM SORBENT TO ABSORB LIQ.REDU CE VAPOR/FIRE HAZ
W/FLUORORCARBON H2O FOAM.(SUPPP)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:PROTECT AGAINST PHYSICAL DAMAGE.
OUTSIDE OR DETACHED STORAGE IS PREFERABLE. INSIDE STORAGE SHOULD BE
IN FLAMM LIQ CABINETS.
Other Precautions:SEPARATE FROM OXIDIZING MATL,SUBSTANCES W/LOW
ELECTROCONDUCTIVITY, WHICH MAY BE IGNITED BY ELECTROSTATIC SPARKS.
SHOULD BE STORED IN CONTAINERS WHICH MEET THE BONDING & GROUNDING
GUIDELINES. STORE AWA Y FROM INCOMPATIBLE SUBSTANCES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:BASED ON CONTAMINATION LEVELS IN THE WORK PLACE.
FOR EXAMPLE 1/2 MASK PURIFYING RESPIRATOR W/ORGANIC VAPOR
CARTRIDGE. SUPPLIED AIR RESPIRATOR OPERATED IN CONTINUOUS FLOW
MODE.
Ventilation:VENTILATION SHOULD MEET THE REQUIREMENTS SET FORTH IN
29CFR1910.1028(F).
Other Protective Equipment:IMPERVIOUS CLOTHING.
Work Hygienic Practices:EYE WASH STATION AND SAFETY SHOWER,
Supplemental Safety and Health
AIR SPILLS:KNOCK DOWN VAPORS W/H2O SPRAY.KEEP UPWIND.H2O SPILL:APPLY
UNIVERSAL GELLING AGENT TO TRAP MATL.
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:=80.C, 176.F
Melt/Freeze Pt:=5.5C, 42.1F
Vapor Pres:75MM @20C
Vapor Density:2.8 (AIR=1
Spec Gravity:0.8765
Evaporation Rate & Reference:5.1 (N-BUTYL ACETATE=1)
Solubility in Water:SLIGHT
Appearance and Odor:COLORLESS TO LIGHT-YELLOW LIQUID WITH AN AROMATIC
ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS;BROMINE;IRON;CHLORINE;NITRIC ACID;OXYGEN;PERCHLORATE;PERMANGANIC
ACID;POTASSIUM PEROXIDE;SILVER PERCHLORATE;UFL5.
Stability Condition to Avoid:AVOID CONTACT WITH HEAT, SPARKS, FLAMES
AND OTHER SOURCES OF IGNITION
Hazardous Decomposition Products:TOXIC OXIDES OF CARBON.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTACT YOUR DISTRICT DIRECTOR OF EPA FOR PROPER
DISPOSAL INFO.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:APOLLO INTERIOR FLAT LATEX, 2200
Preparer's Name:R. MILLER
CAGE:85260
CAGE:85260
============= Composition/Information on Ingredients =============
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 0.28%
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
Ingred Name:SUPP DATA: WHICH IS CLASSED PROBABLY CARCINOGENIC.
RTECS #:9999999ZZ
Ingred Name:EXPLAN CARCIN: GROUP 2A (IARC), GROUP 2 (NTP), OSHA
REGULATED. ACETALDEHYDE: GROUP 2B (IARC).
RTECS #:9999999ZZ
Ingred Name:OTHER PREC: CRYSTALLINE SILICA DUST WHICH HAS BEEN
DESIGNATED AS GROUP 2A, PROBABLY CARCIN TO HUMANS.PROVIDE (SEE ING
5)
RTECS #:9999999ZZ
Ingred Name:INGRED 4: ADEQUATE VENTILATION AND WEAR RESP PROTECTION IF
SANDING.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:INHAL: TRACE COMPONENT & RESIDUAL
MONOMER VAPS MAY BE IRRIT TO EYES, SKIN, MUC MEMB, RESP TRACT, &
MAY PRDCE SYMP OF HDCH, NAUS IN POORLY VENT AREAS. SKIN: PRLNGD
CONTACT MAY CAUSE TRANSIENT REDDENING OF SKIN. EYE: MAY CAUSE
IRRIT. SKIN ABSORP: NO EVIDENCE OF ADVERSE EFTS FROM AVAIL INFORM.
(SEE EFTS OF OVEREXPOS)
Explanation of Carcinogenicity:FORMALDEHYDE: GROUP 2A (IARC), GROU 2
(NTP), OSHA REGULATED. CRYSTALLINE SILICA: GROUP 2A (IARC).
ETHYLENE (SEE ING 3)
Effects of Overexposure:HLTH HAZ: INGEST: NONE EXPECTED. ACUTE &
CHRONIC: PROD CONTAINS CRYSTALLINE SILICA WHICH IS CONSIDERED HAZ
BY INHAL. CRYSTALLINE SILICA HAS BEEN CLASSIFIED AS PROBABLY
CARCINOGENIC FOR HUMANS BY IARC. CRYSTALLINE SILICA IS ALSO KNOWN
CAUSEOF SILICOSIS. VINYL ACETATE MONOMER, A RESIDUAL COMPONENT OF
PROD, (SUPP DATA)
Medical Cond Aggravated by Exposure:NONE EXPECTED.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH IMMED WITH LRG AMTS OF WATER AT LEAST 15
MINUTES.TAKE TO PHYS FOR MED TREATMENT. INGEST: DRINK 1 OR 2
GLASSES OF WATER TO DILUTE. DO NOT INDUCE VOMITING. CONSULT A
PHYSICIAN IMMEDIATELY. SK IN: WASH WITH SOAP AND WATER. INHAL:
REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE ARTIFICIAL
RESPIRATION/O2). CALL MD IMMEDIATELY .
===================== Fire Fighting Measures =====================
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . NON-FLAMMABLE. AFTER WATER EVAPORATES, REMAINING
MATERIAL WILL BURN.
Unusual Fire/Explosion Hazard:PRODUCT WILL NOT BURN BUT MAY SPATTER IF
TEMPERATURE EXCEEDS BOILING POINT OF WATER. DRIED SOLIDS CAN BURN,
GIVING OFF OXIDES OF CARBON.
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN MATERIAL & SCRAPE OR USE ABSORBANT
MATERIAL TO CLEAN UP. TRANSFER TO CONTAINERS FOR DISPOSAL. WASH
AREA WITH WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CLOSURE TIGHT AND CONTAINER
UPRIGHT TO PREVENT LEAKAGE. PROTECT FROM FREEZING. DO NOT TAKE
INTERNALLY, & AVOID PRLNGD SKIN CONTACT/INHALATION.
Other Precautions:REPORTS HAVE ASSOCIATED RPTD & PRLNGD OCCUPATIONAL
OVEREXP TO SOLV W/PERM BRAIN & NERVOUS SYS DAMAGE. INTENTIONAL
MISUSE BY DELIBERATELY CONC & INHALING CONTENTS MAY BE FATAL.
SANDING OF DRIED PAINT F ILM WILL RSLT IN EXPOS TO (SEE ING 4)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED MECH FILTERS TO REMOVE
PARTICLES WHEN APPLYING BY SPRAY. WHEN SANDING DRIED PAINT FILM USE
APPRVD MECH FILTERS DESIGNED TO REMOVE DUSTS. CLEAN UP DUSTS BY
VACUUMING, DO NOT DRY SWEEP WHICH WILL CAUSE EXPOS TO DUST.
Ventilation:MAINTAIN SUFFICIENT VENT TO KEEP AIR CONTAM CONC BELOW OSHA
PERMISSIBLE EXPOS LEVEL.
Other Protective Equipment:NONE REQUIRED.
Work Hygienic Practices:WASH HANDS BEFORE EATING OR SMOKING. SMOKE IN
AUTHORIZED AREAS ONLY.
Supplemental Safety and Health
EFTS OF OVEREXP: IS POS CANCER HAZ BASED ON TESTS W/LAB ANIMALS, VINYL
ACETATE IS NOT CLASSED AS A HUMAN CARCINOGEN. MAY CONTAIN TRACE
AMTS OF FORMADEHYDE, ACETALDEHYDE & ETHYLENE OXIDE WHICH HAVE ALL
BEEN SHOWN TO CAUSE CANCER. ETHYLENE OXIDE IS ALSO LISTED AS
REPRODUCTIVE TOXIN. CONTAINS CRYSTALLINE SILICA(SEE ING 2)
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:212F,100C
Vapor Density:LTR/AIR
Spec Gravity:1.5
Evaporation Rate & Reference:SLOWER THAN ETHER.
Solubility in Water:DILUTABLE.
Appearance and Odor:OPAQUE LIQUID WITH MILD ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID MATERIALS THAT REACT WITH WATER.
Stability Condition to Avoid:AVOID FREEZING CONDITIONS.
Hazardous Decomposition Products:THERMAL DECOMPOSITION OR BURNING WILL
PRODUCE OXIDES OF CARBON.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH FEDERAL, STATE, AND
LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:REAGENT 4 ANTI-N MENINGITIS GRPS C AND W135 ANTIBODY,4952360
Kit Part:Y
Preparer's Name:SAFETY & ENVIRONMENT DEPT
CAGE:05545
CAGE:05545
CAGE:TO577
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM AZIDE
CAS:26628-22-8
RTECS #:VY8050000
= Wt:.2
ACGIH TLV:0.29 MG/M3, 0.11 PPM
ACGIH STEL:C0.29 MG/M3
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:HAZARD DESCRIPTION: NOT APPLICABLE. XN
HARMFUL. INFORMATION PERTAINING TO PARTICULAR DANGERS FOR MAN AND
ENVIRONMENT: R 22 HARMFUL IF SWALLOWED.
======================= First Aid Measures =======================
First Aid:GENERAL INFORMATION: SYMPTOMS OF POISONING MAY EVEN OCCUR
AFTER SEVERAL HOURS; THEREFORE MEDICAL OBSERVATION FOR AT LEAST 48
HOURS AFTER THE ACCIDENT. AFTER INHALATION: SUPPLY FRESH AIR;
CONSULT DOCT OR IN CASE OF COMPLAINTS. AFTER SKIN CONTACT:
GENERALLY THE PRODUCT DOES NOT IRRITATE THE SKIN. AFTER EYE
CONTACT: RINSE OPENED EYE FOR SEVERAL MINUTES UNDER RUNNING WATER.
AFTER SWALLOWING: IMMEDI ATELY CALL A DOCTOR.
===================== Fire Fighting Measures =====================
Lower Limits:NO HAZARD
Upper Limits:NO HAZARD
Extinguishing Media:CO2, EXTINGUISHING POWDER OR WATER SPRAY. FIGHT
LARGER FIRES WITH WATER SPRAY OR ALCOHOL RESISTANT FOAM.
Fire Fighting Procedures:PROTECTIVE EQUIPMENT: NO SPECIAL MEASURES
REQUIRED.
================== Accidental Release Measures ==================
Spill Release Procedures:PERSON-RELATED SAFETY PRECAUTIONS: NOT
REQUIRED. MEASURES FOR ENVIRONMENTAL PROTECTION: PREVENT SEEPAGE
INTO SEWAGE SYSTEM, WORKPITS AND CELLARS. MEASURES FOR
CLEANING/COLLECTING: ABSORB WITH LIQUID -BINDING MATERIAL (SAND,
DIATOMITE, ACID BINDERS, UNIVERSAL BINDERS, SAWDUST). DISPOSE
CONTAMINATED MATERIAL AS WASTE.
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLING: INFORMATION FOR SAFE
HANDLING: NO SPECIAL MEASURES REQUIRED. INFORMATION ABOUT
PROTECTION AGAINST EXPLOSIONS AND FIRES: NO SPECIAL MEASURES
REQUIRED. STORAGE: REQUIREMENTS TO BE MET BY STO REROOMS AND
RECEPTACLES: NO SPECIAL REQUIREMENTS. INFORMATION (OTHER PREC'S)
Other Precautions:HANDLING & STORAGE (CONT): ABOUT STORAGE IN ONE
COMMON STORAGE FACILITY: NOT REQUIRED. FURTHER INFORMATION ABOUT
STORAGE CONDITIONS: NONE. CLASS ACCORDING TO REGULATION ON
FLAMMABLE LIQUIDS: VOID.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED. WHEN NEEDED, NIOSH APPROVED
RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:GENERAL AND/OR LOCAL EXHAUST SUFFICIENT TO MAINTAIN
EXPOSURES BELOW APPLICABLE LIMITS .
Other Protective Equipment:EYEWASH AND DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA .
Work Hygienic Practices:KEEP AWAY FROM FOODSTUFFS, BEVERAGES AND FEED.
WASH HANDS BEFORE BREAKS AND AT THE END OF WORK.
Supplemental Safety and Health
NFPA RATINGS (SCALE 0-4): HEALTH=2, FIRE=0, REACTIVITY=0. COMPONENT
OF: DIRECTIGEN MENINGITIS COMBO TEST KIT.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:UNDETERMINED
Spec Gravity:N/P, DENSITY: NOT DETERM
Appearance and Odor:SOLID W/ CHARACTERISTIC ODOR, COLOR: ACCORDING TO
PRODUCT SPECIFICATION
Percent Volatiles by Volume:0.0% ORG SOL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
SODIUM AZIDE IS PRESENT IN THIS PRODUCT. CONTACT WITH ACIDIC SOLUTIONS
AND METAL COMPOUNDS OVER TIME MAY FORM POTENTIALLY EXPLOSIVE METAL
AZIDES. SHOULD ANY OF THIS MATERIAL BE INTRODUCED INTO A SANITARY
SEWER SYSTEM, FLUSH
Stability Condition to Avoid:NO DECOMPOSITION IF USED ACCORDING TO
SPECIFICATIONS.
Hazardous Decomposition Products:NO DANGEROUS DECOMPOSITION PRODUCTS
KNOWN.
=================== Toxicological Information===================
Toxicological Information:ACUTE TOXICITY: PRIMARY IRRITANT EFFECT: ON
THE SKIN: NO IRRITANT EFFECT. ON THE EYE: NO IRRITANT EFFECT.
SENSITIZATION: NO SENSITIZING EFFECTS KNOWN. ADDITIONAL
TOXICOLOGICAL INFORMATION: WARNING: THIS PRODUCT IS KNOWN TO THE
STATE OF CALIFORNIA TO CAUSE BIRTH DEFECTS, OR OTHER REPRODUCTIVE
HARM.
===================== Ecological Information =====================
Ecological:WATER HAZARD CLASS 0 (SELF-ASSESSMENT): GENERALLY NOT
HAZARDOUS FOR WATER.
==================== Disposal Considerations ====================
Waste Disposal Methods:PRODUCT: MUST NOT BE DISPOSED OF TOGETHER WITH
HOUSEHOLD GARBAGE. DO NOT ALLOW PRODUCT TO REACH SEWAGE SYSTEM.
UNCLEANED PACKAGINGS: DISPOSAL MUST BE MADE ACCORDING TO OFFICIAL
REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:DOT REGULATIONS: HAZARD CLASS: - . LAND
TRANSPORT ADR/RID (CROSS-BORDER): ADR/RID CLASS: - . MARITIME
TRANSPORT IMDG: IMDG CLASS: - . MARINE POLLUTANT: NO. AIR
TRANSPORT ICAO-TI AND IATA-DGR: ICAO/ IATA CLASS: - .
===================== Regulatory Information =====================
Federal Regulatory Information:PRODUCT RELATED HAZARD INFORMATIONS: THE
PRODUCT HAS BEEN CLASSIFIED AND MARKED IN ACCORDANCE WITH
DIRECTIVES ON HAZARDOUS MATERIALS.HAZARD SYMBOLS: XN HARMFUL.
RISK PHRASES: 22 HARMFUL IF SWALLOW ED. SAFETY PHRASES: 2 KEEP
OUT OF REACH OF CHILDREN. 13 KEEP AWAY FROM FOOD, DRINK AND ANIMAL
FEEDINGSTUFFS. 36 WEAR SUITABLE PROTECTIVE CLOTHING. 46 IF
SWALLOWED, SEEK MEDICAL ADVICE IMMEDIATELY AN D SHOW THIS CONTAINER
OR LABEL. NATIONAL REGULATIONS: WATER HAZARD CLASS: WATER HAZARD
CLASS 0 (SEL F ASSESSMENT): GENERALLY NOT HAZARDOUS FOR WATER.
State Regulatory Information:WARNING: THIS PRODUCT IS KNOWN TO THE
STATE OF CALIFORNIA TO CAUSE BIRTH DEFECTS, OR OTHER REPRODUCTIVE
HARM.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:HEA 3/8 INCH
CAGE:EO264
CAGE:11239
CAGE:EO264
============= Composition/Information on Ingredients =============
Ingred Name:COMPONENT A (CONSISTING OF INGREDIENTS 2-4)
RTECS #:9999999ZZ
Fraction by Wt: 100%
Ingred Name:STYRENE (SARA III). BP:293F,145C. VP:6 @ 68F. VAP
DENSITY:3.6.
CAS:100-42-5
RTECS #:WL3675000
Fraction by Wt: 8.4%
OSHA PEL:100 PPM
ACGIH TLV:S,50PPM/100STEL;9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:VINYL ESTER RESIN
Fraction by Wt: 13.2%
Ingred Name:INORGANIC MATERIALS (NOT SPECIFIED)
Fraction by Wt: 78.4%
Ingred Name:COMPONENT B (CONTAINING INGREDIENTS 6-8)
RTECS #:9999999ZZ
Fraction by Wt: 100%
Ingred Name:BENZOYL PEROXIDE; (DIBENZOYL PEROXIDE)
CAS:94-36-0
RTECS #:DM8575000
Fraction by Wt: 4.5%
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3
Ingred Name:SOFTENER
Fraction by Wt: 21.6%
Ingred Name:INORGANIC MATERIALS (NOT SPECIFIED)
Fraction by Wt: 73.9%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:IRRITATED EYES, SKIN AND BREATHING
PASSAGES.
Explanation of Carcinogenicity:STYRENE:GROUP 2B, IARC (IARC MONOGRAPH
VOLUME SUPPLEMENT 7, PAGE 345, 19887) .
Effects of Overexposure:HEADACHE, SKIN IRRITATION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD IMMEDIATELY . SKIN:WASH WITH SOAP AND WATER.
EYES:SHOULD BE RINSED IMMEDIATELY WITH RUNNING WATER CONTINUOUSLY
FOR AT LEAST 15 MINUTES. CONTACT AN OPHTHALMOLOGIST. INHAL:REMOVE
TOFRESH AIR.
===================== Fire Fighting Measures =====================
Flash Point:93F,33.9C
Lower Limits:1.1%
Upper Limits:6.1%
Extinguishing Media:POWDER-TYPE FIRE EXTINGUISHERS.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:CONTENTS OR DAMAGED CARTRIDGES SHOULD BE
CAREFULLY ABSORBED WITH A SUITABLE MATERIAL AND DISPOSED OF IN
ACCORDANCE WITH LOCAL REGULATIONS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN ORIGINAL PACKAGING AWAY FROM
OPEN FLAMES, HEAT SOURCES, DIRECT SUNLIGHT AND SPARKS.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:SUPPLY CLOSED ROOMS WITH FRESH AIR.
Other Protective Equipment:FREQUENTLY CLEAN PROTECTIVE CLOTHING, SHOES
ETC TO AVOID SKIN CONTACT WITH STYRENE.
Work Hygienic Practices:NO SMOKING. AVOID SKIN CONTACT. WASH HANDS
BEFORE EATING.
Supplemental Safety and Health
SPEC GRAVITY:COMPONENT A:1.07. COMPONENT B:2.61 (H*2O = 1).
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:ING 2
Vapor Pres:ING 2
Vapor Density:ING 2
Spec Gravity:SUPDAT
Evaporation Rate & Reference:1.39 (BUTYL ACETATE = 1)
Solubility in Water:INSOLUBLE
Appearance and Odor:LIGHT YELLOW LIQUID/WHITE POWDER/TYPICAL AROMATIC
ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, PEROXIDES AND OTHER OXIDIZING AGENTS.
Stability Condition to Avoid:PRODUCT IS STABLE AT TEMPERATURES BELOW
122F.
Hazardous Decomposition Products:CO, CO*2, LOW MOLECULAR WEIGHT
HYDROCARBONS AND INORGANIC ACIDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH LOCAL, STATE
AND FEDERAL REGULATIONS . IF A LARGE AMOUNT OF WASTE IS INVOLVED,
DISPOSE OF ACCORDING TO LOCAL REGULATIONS AT WASTE DISPOSAL SITE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:HEAVY DUTY HAND CLEANER, 1141
Preparer's Name:RONALD A WILLIAMS
CAGE:02905
CAGE:02905
============= Composition/Information on Ingredients =============
Ingred Name:NONYLPHENOL POLYETHOXATE; (NONIONIC SURFACTANTS)
CAS:9016-45-9
RTECS #:MD0900000
Fraction by Wt: 3-7%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:STODDARD SOLVENT; (PETROLEUM DISTILLATES)
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 40-70%
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATES, HYDROTREATED (SEVERE)
LIGHT PARAFFINIC; (PETROLEUM DISTILLATES)
CAS:64742-55-8
RTECS #:PY8036501
OSHA PEL:5 MG/M3 (MFR)
ACGIH TLV:5 MG/M3 (MFR)
Ingred Name:PROPYLENE GLYCOL
CAS:57-55-6
RTECS #:TY2000000
Fraction by Wt: 1-5%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES: IRRIT. SKIN: PROLONGED
CONT MAY RESULT IN CONT DERMATITIS WHICH IS CHARACTERIZED BY
DRYNESS, CHAPPING, & REDDENING. INGEST: SMALL QUANTITIES ARE
USUALLY NONFATAL UNLESS ASPIR OCCURS. ASPI RATION MAY LEAD TO
CHEMICAL PNEUMONITISWHICH IS CHARACTERIZED BY PULMONARY EDEMA &
HEMORRHAGE, & MAY BE FATAL.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:PREEXISTING SKIN OR RESPIRATORY
CONDITIONS.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR AT LEAST 15 MINUTES, IF IRRIT
PERSISTS CONT MD. INGEST: DO NOT INDUCE VOMIT, CONTAINS PETROLEUM
DISTILLATES. IF VOMITING OCCURS, LOWER VICTIM'S HEAD BELOW HIS
KNEES TO AVOID AS PIRATION. CONT MD/POISON CONTROL
CENTERIMMEDIATELY. SKIN: FLUSH W/COPIOUS AMOUNTS OF WATER. SEE MD .
INHAL: REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE
OXYGEN/ARTIFICIAL RESPIRATION) .
===================== Fire Fighting Measures =====================
Flash Point:SUP DAT
Lower Limits:1.1%
Upper Limits:6.0%
Extinguishing Media:ALCOHOL FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:DENSE SMOKE MAY BE GENERATED DURING
COMBUSTION. CARBON MONOXIDE, CARBON DIOXIDE, AND OTHER TOXIC OXIDES
MAY BE GENERATED AS PRODUCTS OF COMBUSTION.
================== Accidental Release Measures ==================
Spill Release Procedures:DO NOT ALLOW SPILL TO ENTER
SEWERS/WATERCOURSES. REMOVE ALL SOURCES OF IGNITION & ALLOW FOR
ADEQUATE VENT. ABSORB ONTO INERT ABSORBENT MEDIUM & COLLECT FOR
DISPOSAL IN AN APPROVED CONTAINER. RINSE ARE A W/WATER TO REDUCE
POSSIBLE SLIPPERY FLOOR HAZ.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL AREA WAY FROM HEAT,
SPARKS, OPEN FLAME OR STRONG OXIDIZING MATERIALS. AVOID EYE CONTACT
AND PROLONGED SKIN CONTACT.
Other Precautions:KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED IF USED AS DIRECTED. USE NIOSH
APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:NONE REQUIRED IF USED AS DIRECTED.
Other Protective Equipment:NONE REQUIRED IF USED AS DIRECTED. EMERGENCY
EYEWASH AND DELUGE SHOWER MEETING ANSI DESIGN CRITERIA .
Work Hygienic Practices:ROUTINE.
Supplemental Safety and Health
PH (UNDILUTED): 8.6-9.6. FL PT: BOILS BEFORE FLASH.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:180F,82C
Vapor Pres:10 @ 100F
Vapor Density:4-5
Spec Gravity:0.9 (H*2O=1)
pH:SUPDAT
Evaporation Rate & Reference:<1.0 (EE=1)
Solubility in Water:SLIGHT
Appearance and Odor:WHITE OPAQUE GEL, PLEASANT ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MAY REACT WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:NONE KNOWN.
==================== Disposal Considerations ====================
Waste Disposal Methods:IN ACCORDANCE WITH ALL LOCAL, STATE, AND FEDERAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:STAINLESS STEELS PH 17-4
CAGE:52660
CAGE:52660
CAGE:9Y791
============= Composition/Information on Ingredients =============
Ingred Name:TANTALUM (AS METAL TA)
CAS:7440-25-7
RTECS #:WW5505000
Fraction by Wt: <0.5%
OSHA PEL:5 MG/M3 DUST
ACGIH TLV:5 MG/M3 DUST
Ingred Name:NITROGEN
CAS:7727-37-9
RTECS #:QW9700000
Fraction by Wt: <0.1%
ACGIH TLV:SIMPLE ASPHYXIANT
Ingred Name:IRON (AS IRON OXIDE FUME)
CAS:7439-89-6
RTECS #:NO4565500
Fraction by Wt: >74%
OSHA PEL:10 (FE) MG/M3
ACGIH TLV:5 (FE) MG/M3
Ingred Name:MANGANESE (SARA III)
CAS:7439-96-5
RTECS #:OO9275000
Fraction by Wt: <1%
OSHA PEL:(C) 5 MG/M3 DUST
ACGIH TLV:5 MG/M3 DUST 9293
Ingred Name:CARBON
CAS:7440-44-0
RTECS #:FF5250100
Fraction by Wt: <0.1%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:2 MG/M3 TDUST; 9293
Ingred Name:PHOSPHOROUS (YELLOW) (SARA III)
CAS:7723-14-0
RTECS #:TH3500000
Fraction by Wt: <0.1%
OSHA PEL:0.1 MG/M3
ACGIH TLV:0.1 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SULFUR (AS SULFUR DIOXIDE) (SARA III)
CAS:7704-34-9
RTECS #:WS4250000
Fraction by Wt: <0.1%
OSHA PEL:2 PPM; 5 PPM STEL
ACGIH TLV:2 PPM; 5 PPM STEL
Ingred Name:SILICON
CAS:7440-21-3
RTECS #:VW0400000
Fraction by Wt: <1%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:CHROMIUM (VI); (AS SOLUBLE CR SALTS) (SARA III)
CAS:7440-47-3
RTECS #:GB4200000
Fraction by Wt: <17%
OSHA PEL:0.5 MG/M3
ACGIH TLV:0.5 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:NICKEL (AS METAL NI) (SARA III)
CAS:7440-02-0
RTECS #:QR5950000
Fraction by Wt: <5%
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3
Ingred Name:COLUMBIUM
CAS:7440-03-1
Fraction by Wt: <0.5%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: DUST/FUME MAY CAUSE IRRIT TO
EYES/ NOSE/ THROAT; LEAVE A METALLIC TASTE IN MOUTH; RSLT IN METAL
FUME FEVER; OR PRDCE FLU-LIKE SYMP. CHRONIC: CHROMIUM: SKIN
ULCERATION, IRRITATIVE DERMAT, ALLERG IC RXN, ULCERATION OF MUC
MEMB, PERFORATION OF NASAL SEPTUM, BRONCH CARCINOMA,
ADENOCARCINOMA, MUTAGEN. (EFT OF OVEREXP)
Explanation of Carcinogenicity:CHROMIUM: KNOWN CARCINOGEN (NTP), GROUP
1 (IARC). NICKEL: ANTICIPATED TO BE CARCINOGEN (NTP), GROUP 2B
(IARC).
Effects of Overexposure:HLTH HAZ: IRON: SIDEROSIS. MANGANESE:
BRONCHITIS, PNEUMONITIS, LACK OF COORDINATION. NICKEL: INFLAMMATION
OF RESPIRATORY TRACT, PNEUMOCONIOSIS. SKIN SENSITIZER, CERTAIN
NICKEL COMPOUNDS CAN CAUSE CANC ER. PHOSPHORUS: NECROSIS OF THE
MANDIBLE. SULFUR: EDEMA OF THE LUNGS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL: IN THE EVENT OF ACUTE EXPOSURE, REMOVE TO FRESH AIR,
ADMINISTER OXYGEN, AND SEEK MD ASSISTANCE. INGEST: CALL MD
IMMEDIATELY . EYES: IMMEDIATELY FLUSH W/POTABLE WATER FOR A MINIMUM
OF 15 M INUTES, SEEK ASSISTANCE FROM MD .SKIN: FLUSH W/ COPIOUS
AMOUNTS OF WATER. CALL MD .
===================== Fire Fighting Measures =====================
Extinguishing Media:USE METHODS APPLICABLE TO SURROUNDING FIRE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Other Precautions:PLASMA ARC CUTTING OR WELDING CAN GENERATE OZONE.
OVEREXPOS CAN RESULT IN MUCUOUS MEMBRANE IRRITATION, AS WELL AS
PULMONARY CHANGES INCLUDING IRRITATION, CONGESTION AND EDEMA.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF OPERATIONS ARE SUCH THAT ATMOSPHERIC LEVELS
OF CONTAMINANTS EXCEED PRESCRIBED LIMITS, PROVIDE ADEQ NIOSH/MSHA
APPRVD RESP PROT. CONSULT REGIONAL CFR29 PART 1910.252, WELDING,
CUTTING & BRAZING, 191 0.134, RESPIRATORY PROTECTION.
Ventilation:IF OPERATIONS ARE SUCH THAT ATM LEVELS OF CONTAMINANTS
EXCEED PRESCRIBED LIMITS, PROVIDE LOCAL EXHAUST VENTILATION.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
APPEAR/ODOR: PIPE OR TUBING.
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:>2550F,>139
Spec Gravity:>7 (H2O=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:GRAYISH TO SILVERY ODORLESS SHEET, STRIP, PLATE,
BAR, STRUCTURAL SHAPE,(SUPDATA
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NOT INCOMPATIBLE WITH MATERIALS.
Stability Condition to Avoid:MAY LIBERATE METAL FUMES, METAL OXIDES, OR
OTHER OXIDES IF EXPOSED TO ELEVATED TEMPERATURES.
==================== Disposal Considerations ====================
Waste Disposal Methods:MATL MAY BE RECLAIMED FOR REUSE. ACID PICKLING
OF PROD MAY RSLT IN FORMATION OF HEXAVALENT CHROMIUM WHICH IS A HAZ
WASTE. CONSULT REGIONAL CFR29 1910-SUBPART Z, TOXIC & HAZARDOUS
SUBSTANCES. DISPOSAL MUST BE I/A/W FEDERAL, STATE, & LOCAL REGS .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:HI-84, L-TEC SPOOLARC & OXWELD SOLID STEEL (SUP DAT)
CAGE:HO829
CAGE:84021
CAGE:HO829
============= Composition/Information on Ingredients =============
Ingred Name:CARBON
CAS:7440-44-0
RTECS #:FF5250100
Fraction by Wt: <0.5%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:2 MG/M3 TDUST
Ingred Name:IRON; (FE)
CAS:7439-89-6
RTECS #:NO4565500
Fraction by Wt: BALANCE
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:MANGANESE; (MN) (SARA 313)
CAS:7439-96-5
RTECS #:OO9275000
Fraction by Wt: 1-2%
OSHA PEL:C 5 MG/M3 DUST
ACGIH TLV:5 MG/M3 DUST
Ingred Name:SILICON; (SI)
CAS:7440-21-3
RTECS #:VW0400000
Fraction by Wt: <1%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:COPPER; (CU) (SARA 313) (CERCLA)
CAS:7440-50-8
RTECS #:GL5325000
Fraction by Wt: <0.5%
OSHA PEL:0.1MG/M3 FUME/1 DUST
ACGIH TLV:0.2 MG/M3 FUME
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:MOLYBDENUM; (MO)
CAS:7439-98-7
RTECS #:QA4680000
Fraction by Wt: 0.5%
OSHA PEL:10 PPM
ACGIH TLV:10 PPM
Ingred Name:TITANIUM; (TI)
CAS:7440-32-6
RTECS #:XR1700000
Fraction by Wt: <0.1%
OSHA PEL:5 MG/M3 (MFR)
ACGIH TLV:10 MG/M3 (MFR)
Ingred Name:SUP DAT: IN ATM. REASONABLY EXPECTED DECOMP PRODS FROM NORM
USE INCL COMPLEX OXIDES OF MATLS IN INGS SECTION, AS (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8: WELL AS CARBON MONOXIDE & DIOXIDE, OZONE & NITROGEN
OXIDES. THE ONLY WAY TO DETERMINE TRUE IDENTITY OF (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9: DECOMP PRODS IS BY SAMPLING & ANALYSIS. COMPOSITION
& QTY OF FUMES & GASES CAN BE DETERMINED FROM SAMPLE (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10: OBTAINED FROM INSIDE WELDER'S HELMET, IF WORN/IN
WORKERS BRTHG ZONE. FOR MORE SPECIFIC INFO CONT NEHC .
RTECS #:9999999ZZ
Ingred Name:EFTS OF OVEREXP: IRRIT OF NASAL MEMB & SKIN. NICKEL CMPDS
IN FUME CAN CAUSE METALLIC TASTE, NAUS, TIGHTNESS OF (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12: CHEST, FEVER, & ALLERGIC RXN. CHRONIC (LONG TERM)
OVEREXP TO AIR CONTAMINANTS MAY LEAD TO THEIR ACCUM IN(ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13: LUNGS, CNDTN WHICH MAY BE SEEN AS DENSE AREAS ON
CHEST X-RAYS. SEV OF CHANGE IS PROPORTIONAL TO LENGTH (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14: OF EXPOS. CHANGES ARE NOT NEC ASSOC W/SYMPS/SIGNS
OF REDUCED LUNG FUNC/DISEASE. LONG TERM OVEREXP TO (ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15: NICKEL FUMES MAY ALSO CAUSE PULM FIBROSIS & EDEMA.
OVEREXP TO MANGANESE CMPDS MAY AFFECT CNS, SYMPS OF (ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16: WHICH ARE LANGOUR, SPEEPINESS, MUSC WEAK, EMOTIONAL
DISTURB & SPASTIC GAIT. CONT NEHC FOR MORE INFO .
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC: . SKIN: FLUSH WITH COPIOUS AMOUNTS OF
WATER. SEE MD . INGESTION: CALL MD IMMEDIATELY .
RTECS #:9999999ZZ
Ingred Name:EYE PROT: LENS. AS A RULE OF THUMB, START W/SHADE WHICH IS
TOO DARK TO SEE WELD ZONE. THEN GO TO NEXT LIGHTER (ING 20)
RTECS #:9999999ZZ
Ingred Name:ING 19: SHADE WHICH GIVES SUFFICIENT VIEW OF WELD ZONE.
PROVIDE PROT SCREENS & FLASH GOGG, IF NEC, TO SHIELD OTHERS.
RTECS #:9999999ZZ
Ingred Name:OTHER PROT EQUIP: SPKS & ELEC SHOCK. AT MIN, THIS INCL
RTECS #:9999999ZZ
Ingred Name:ING 21: APRONS, HATS, SHOULDER PROTECTION, AS WELL AS DARK
SUBSTANTIAL CLOTHING.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: FUMES & GASES CAN BE DANGEROUS
TO HLTH. ELEC SHOCK CAN KILL. ARC RAYS CAN INJURE EYES & BURN SKIN.
NOISE CAN DMG HEARING. ABSORPTION BY SKIN CONT IS UNLIKELY. WHEN
PRODS ARE USED AS REC BY MFR, & VENT MAINTAINS EXPOS TO DECOMP
PRODSBELOW LIMS REC IN THIS SECTION, OVEREXP IS UNLIKELY. EFTS OF
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: OVEREXP TO GASES, FUMES & DUSTS MAY
INCL IRRIT OF EYES, LUNGS, NOSE & THROAT. SOME TOX GASES ASSOC
W/WELDING MAY CAUSE PULM EDEMA, ASPHY, & DEATH. ACUTE OVEREXP MAY
INCL WATERY EYES, NOSE & THROAT IRRIT, HDCH, DIZZ, DFCLTY IN
BRTHG, FREQUENT COUGHING/CHEST PAIN. CHROMIUM/CHROMATE IN FUME CAN
CAUSE (ING 12)
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH ALLERGIES OR
IMPAIRED RESPIRATORY FUNCTION. SUCH REACTION CANNOT BE PREDICTED
DUE TO VARIATION IN COMPOSITION & QUANTITY OF DECOMPOSITION
PRODUCTS.
======================= First Aid Measures =======================
First Aid:IN CASE OF EMER, CALL FOR MED AID. EMPLOY FIRST AID
TECHNIQUES REC BY RED CROSS. INHAL: IF BRTHG IS DFCLT, GIVE OXYGEN
& CALL FOR MD. FOR ELEC SHOCK, DISCONNECT & TURN OFF POWER. IF NOT
BRTHG, BEGIN A RTF RESP, PREF MOUTH-TO-MOUTH. IF NO DETECTABLE
PULSE, BEGIN CPR. IMMED CALL MD. FOR ARC BURN, APPLY COLD, CLEAN
COMPRESSES & CALL MD. EYES: FLUSH W/POTABLE WATER FOR AT LEAST 15
MIN. SEE MD (ING 18)
===================== Fire Fighting Measures =====================
Extinguishing Media:PROD WILL NOT BURN. USE EXTING MEDIA REC FOR
BURNING MATLS & FIRE SITUATION. CONT NEHC FOR MORE SPECIFIC INFO .
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:ONLY THE PACKAGING FOR THIS PRODUCT WILL
BURN. HOWEVER, WELDING ARCS AND SPARKS CAN IGNITE COMBUSTIBLE AND
FLAMMABLE MATERIALS.
================== Accidental Release Measures ==================
Spill Release Procedures:NOT APPLICABLE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:TRAIN THE WELDER NOT TO TOUCH LIVE
ELECTRICAL PARTS AND TO INSULATE HIMSELF FROM WORK AND GROUND.
Other Precautions:TRAIN WELDER TO KEEP HIS HEAD OUT OF THE FUMES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED RESPIRABLE FUME RESPIRATOR OR
AIR SUPPLIED RESPIRATOR WHEN WELDING IN CONFINED SPACES OR WHERE
LOCAL EXHAUST OR VENTILATION DOES NOT KEEP EXPOSURE BELOW TLV.
Ventilation:USE ENOUGH VENT, LOC EXHAUST AT ARC/BOTH, TO KEEP FUMES &
GASES BELOW TLV IN WORKER'S BREATHING ZONE & GENERAL AREA.
Other Protective Equipment:ANSI APPRVD EMER EYEWASH & DELUGE SHOWER .
WEAR HEAD, HANDS & BODY PROT W/HELP TO PVNT INJURY FROM RADIA, (ING
21)
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
TRADE NAME/PART #: WELDING ELECTRODES & RODS. HAZ DECOMP PROD: WORKED,
PROCESS, PROC & CONSUMABLES USED. OTHER CNDTNS INCL: COATINGS ON
MATL BEING WORKED, NUMBER OF WELDING OPERATIONS & VOL OF WORK AR
EA, QUALITY & AMT OF VENT, POSITION OF WORKERS HEAD W/RESPECT TO
FUME PLUME, AS WELL AS PRESENCE OF CONTAMINANTS (ING 8)
================== Physical/Chemical Properties ==================
Appearance and Odor:COPPER-COATED OR BARE, SOLID STEEL WIRE OR ROD,
ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE CURRENTLY KNOWN.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:WELDING FUMES & GASES CANNOT BE
CLASSIFIED SIMPLY. COMPOSITION & QTY OF BOTH ARE DEPENDENT UPON
MATL BEING (SUP DAT)
==================== Disposal Considerations ====================
Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT, RESIDUE, DISPOSABLE CONTAINER OR
LINER, IN AN ENVIRONMENTALLY ACCEPTABLE MANNER, IN FULL COMPLIANCE
WITH FEDERAL, STATE A ND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PCB RISC WIPE TEST KIT, POLYCHLORINATED (SUPP DATA)
Kit Part:Y
CAGE:ENSYS
CAGE:ENSYS
============= Composition/Information on Ingredients =============
Ingred Name:POLYCHLORINATED BIPHENYL (AROCHLOR 1254); (AROCLOR 1248)
(SARA III)
CAS:11097-69-1
RTECS #:TQ1360000
Fraction by Wt: <0.1%
OSHA PEL:0.5 MG/M3, S
ACGIH TLV:0.5 MG/M3, S
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:METHYL ALCOHOL; (METHANOL)(SARA III)
CAS:67-56-1
RTECS #:PC1400000
Fraction by Wt: >99.9%
OSHA PEL:200 PPM;250 STEL, S
ACGIH TLV:200 PPM;250 STEL, S
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL: HARMFUL IF INHALED, MAY BE
FATAL IF SWALLOWED. HEADACHE, NAUSEA, BLINDNESS, GASTROINTESTINAL
DISTURBANCE. CONTAINS LOW CONCENTRATION OF MATERIAL KNOWN TO CAUSE
CANCER. SUCH CONC IS SUBSTATIALLY BELOW THE OSHA THRESHOLD(S)
WHICH WOULD REQUIRE LISTING AS A COMPONENT OF THIS SOLUTION.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE SUBJECT TO FRESH AIR. SEEK MEDICAL ATTENTION IF
NECESSARY. EYE/SKIN: FLUSH EYES OR SKIN WITH COPIOUS AMOUNTS OF
WATER (FLUSH EYES FOR @ LST 15 MIN). WASH CONTAMINATED CLOTHING
BEFORE REU SE. CONSULT A PHYSICIAN IF IRRITATION PERSISTS. INGEST:
GET MD IMMEDIATELY .
===================== Fire Fighting Measures =====================
Extinguishing Media:ALCOHOL FOAM, CO*2, DRY CHEMICAL, WATER SPRAY.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:FIRE HAZARD WHEN EXPOSED TO HEAT, FLAME,
OR OXIDIZERS. VAPORS ARE EXPLOSIVE.
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN SPILL AND TAKE UP WITH ABSORBENT
MATERIAL. ELIMINATE IGNITION SOURCES. VENTILATE AREA.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN SEALED CONTAINER IN A COOL,
DRY LOCATION. KEEP AWAY FROM OXIDIZERS AND/OR IGNITION SOURCES.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED WITH GOOD VENTILATION. OTHERWISE,
WEAR NIOSH/MSHA APPROVED RESPIRATOR WITH ORGANIC VAPOR CANISTER.
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
MFR TRADE NAME/PART NO: BIPHENYL STANDARD.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:149F,65C
Melt/Freeze Pt:M.P/F.P Text:-144F,-98C
Solubility in Water:100%
Appearance and Odor:CLEAR COLORLESS LIQUID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS, CHROMICANHYDRIDE, LEAD PERCHLORATE, PERCHLORIC ACIDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:OBSERVE ALL FEDERAL, STATE AND LOCAL
REQUIREMENTS.
| 1 | gloves_mandatory |
=======================================================
Product ID: COMPACT FLUORESCENT LAMPS, PL-S 7W
Cage: 7Z736
Box: 6800
=======================================================
Contractor Summary
=======================================================
Cage: 7Z736
Box: 6800
Cage: 0BWY7
=======================================================
Ingredients
=======================================================
% Wt: <2
OSHA PEL: 15 MG/M3 (MFR)
ACGIH TLV: 10 MG/M3 (MFR)
-----------------------------
Cas: 1314-36-9
RTECS #: ZG3850000
OSHA PEL: 1 MG/M3 (MFR)
ACGIH TLV: 3 MG/M3 (MFR)
------------------------------
OSHA PEL: 10 MG/M3 (MFR)
ACGIH TLV: N/K (FP N)
-----------------------------
OSHA PEL: 10 MG/M3 (MFR)
ACGIH TLV: N/K (FP N)
-----------------------------
% Wt: <15 NCI
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
Cas: 7439-97-6
RTECS #: OV4550000
% Wt: <0.02
OSHA PEL: C, 0.1 MG/M3; Z-2
ACGIH TLV: S,0.025 MG/M3; A4;95
EPA Rpt Qty: 1 LB
DOT Rpt Qty: 1 LB
------------------------------
AFFECT THE METHOD OF LAMP DISPOSAL. IF SPENT
-----------------------------
QUANTITIES, DISPOSAL OF LAMPS MAY BE
-----------------------------
TO ASSURE THAT THEY ARE PROPERLY
-----------------------------
REGULATIONS.
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: NO
Skin: NO
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: HLTH HAZ: THROUGH THE USE OF ADEQUATE
VENTILATION DURING DISPOSAL OF LARGE QUANTITIES OF LAMPS. MERCURY APPEARS ON
THE NAVY LISTING OF OCCUPATIONAL CHEMICAL REPRODUCTIVE HAZARDS. SEEK
CONSULTATION FRO M APPROPRIATE HEALTH PROFESSIONALS CONCERNING LATEST HAZARD
LIST INFORMATION & SAFE HANDLING & EXPOSURE INFO (FP N).
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: NORMAL FIRST AID PROCEDURE FOR GLASS CUTS IF SUCH OCCUR THROUGH LAMP
BREAKAGE. INGEST: CALL MD IMMEDIATELY (FP N). INHAL: REMOVE TO FRESH AIR.
SUPPORT BREATHING (GIVE O*2/ARTF RESP) (FP N). EYES: IMME DIATELY FLUSH
W/POTABLE WATER FOR A MINIMUM OF 15 MINUTES, SEEK ASSISTANCE FROM MD (FP N).
SKIN: FLUSH W/COPIOUS AMOUNTS OF WATER. CALL MD (FP N).
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: NORMAL PRECAUTIONS SHOULD BE TAKEN FOR COLLECTION OF
BROKEN GLASS.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: UNDER NEW TOXICITY CHARACTERISTIC LEACHING PROCEDURES
(TCLP) PROMULGATED BY US ENVIRONMENTAL PROTECTION AGENCY (EPA), TESTS OF
USED/SPENT FLUORESCENT, INCANDESCENT, & HIGH INTENSITY DISCHARGE LAMPS IN
DICATE THAT SOME TYPES OF THESE (SUPDAT)
WORN WHEN DISPOSING OF LAMPS OR HANDLING BROKEN GLASS.
Other Precautions: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Extinguishing Media: MEDIA SUITABLE FOR SURROUNDING FIRE (FP N).
Fire Fighting Procedures: USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: UNDER EXTREME HEAT, GLASS ENVELOPE MIGHT MELT OR
CRACK.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NIOSH-APPROVED RESPIRATOR MIGHT BE USED IF LARGE
VOLUMES OF LAMPS ARE BEING BROKEN FOR DISPOSAL.
Ventilation: AVOID INHALATION OF ANY AIRBORNE DUST. PROVIDE LOCAL EXHAUST WHEN
DISPOSING LARGE QUANTITIES OF LAMPS.
Other Protective Equipment: EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET ANSI
DESIGN CRITERIA (FP N).
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: WASTE DISP METH: LAMPS MAY BE CLASSIFIED AS
CHARACTERISTIC HAZ WASTE. NOTABLY, TCLP TEST RSLTS FOR FLUORESCENT LAMPS VARY
TREMENDOUSLY FROM LAB TO LAB. LAMPS FROM ALL MFRS EXHIBIT SAME PHENOMENA. THE
NATIONAL ELECTRICAL MFRS ASSOCIATION (NEMA) IS WORKING CLOSELY W/EPA FOR
CLARIFICATION & GUIDANCE. SMALL NUMBERS
=======================================================
Physical/Chemical Properties
=======================================================
Appearance and Odor: THIS IS A LIGHT BULB WITH GLASS TUBES AND PLASTIC BASE.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: GLASS WILL REACT WITH HYDROFLUORIC ACID.
Hazardous Decomposition Products: NONE SPECIFIED BY MANUFACTURER.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: COMPACT FLUORESCENT LAMPS, PL-S 7W
Cage: 7Z736
Company Name: PHILIPS LIGHTING COMPANY
Street: 200 FRANKLIN SQUARE DRIVE
PO Box: 6800
Zipcode: 08875
Label Required IND: Y
Date Of Label Review: 07/22/1998
Status Code: C
Label Date: 07/22/1998
Origination
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: Slight
Reactivity Hazard: None
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:422 FIBERGLASS RESIN
Kit Part:Y
CAGE:16522
CAGE:16522
============= Composition/Information on Ingredients =============
Ingred Name:PROPYLENE GLYCOL, PHTHALIC ANHYDRIDE, MALEIC ANHYDRIDE
RESIN *96-4*
CAS:25037-66-5
Fraction by Wt: <65%
Ingred Name:STYRENE, STYRENE MONOMER (SUSPECTED ANIMAL/HUMAN
CARCINOGEN BY IARC GROUP 2B) *96-4*
CAS:100-42-5
RTECS #:WL3675000
Fraction by Wt: 35%
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:VOLATILE ORGANIC CONTENT: 386 GM/L
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EYES: MAY CAUSE IRRITATION. SKIN:
IRRITATION & DERMATITIS. STYRENE MAY BE ABSORBED IN TOXIC AMOUNTS.
INHALATION: MUCOUS MEMBRANE IRRITATION & CNS EFFECTS.
Explanation of Carcinogenicity:SEE INGREDIENTS.
Effects of Overexposure:IRRITATION, TEARING, DEFATTING, DRYNESS, UPPER
RESPIRATROY TRACT DISCOMFORT, HEADACHE, NAUSEA, INSENSIBILITY, GI
DISTURBANCES, PAIN, DISCOMFORT.
Medical Cond Aggravated by Exposure:CHRONIC RESPIRATORY CONDITIONS,
ASTHMA, CHRONIC BRONCHITIS, EMPHYSEMA.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/PLENTY OF WATER FOR 15 MINS. SKIN: WASH W/SOAP
& WATER. INHALATION: REMOVE TO FRESH AIR. GIVE CPR/OXYGEN IF
NEEDED. INGESTION: DON'T INDUCE VOMITING. ASPIRATION HAZARD. OBTAIN
MEDICAL AT TENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:90F (SUPP)
Lower Limits:1.1
Upper Limits:6.1 (SUPP)
Extinguishing Media:SMALL: CO2, DRY CHEMICAL. LARGE: FOAM, WATER FOG.
Fire Fighting Procedures:WEAR SCBA. COOL CONTAINERS W/WATER.
Unusual Fire/Explosion Hazard:HIGH TEMP EXPOSURE FOR EXTENDED PERIODS
OF TIME WILL RESULT IN SPONTANEOUS UNCONTROLLED EXOTHERMIC
POLYMERIZATION.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE IGNITION SOURCES. VENTILATE AREA.
ABSORB W/AN ABSORBENT MATERIAL, SAWDUST, VERMICULITE/SAND & PLACE
IN A CLOSED CONTAINER. LARGE: DIKE AREA TO PREVENT MATERIAL FROM
ENTERING WATER SYSTEMS/SEWER S.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T STORE >100F. AVOID
PROLONGED/REPEATED SKIN CONTACT. KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR APPROPRIATE ORGANIC VAPOR RESPIRATOR BASED
UPON TYPE & MAGNITUDE OF EXPOSURE IF PELS/TLVS ARE EXCEEDED.
Ventilation:GENERAL: REQUIRED DURING NORMAL USE. LOCAL: MAY BE REQUIRED
DURING CERTAIN OPERATIONS TO KEEP EXPOSURE LEVELS <TLVS.
Other Protective Equipment:POLYVINYL ALCOHOL & POLYEHTYLENE PROTECTIVE
GARMENTS, EYE WASH STATIONS & SAFETY SHOWERS
Work Hygienic Practices:WASH W/SOAP & WATER AFTER HANDLING.
Supplemental Safety and Health
BOILING POINT, VAPOR PRESSURE/DENSITY, FLASH POINT & UPPER EXPLOSIVE
LIMIT INFORMATION IS FOR STYRENE.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:293F (SUPP)
Vapor Pres:5.2 (SUPP)
Vapor Density:3.6 (SUPP)
Spec Gravity:1.1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR, VISCOUS LIQUID W/SHARP STYRENATED ODOR.
Percent Volatiles by Volume:35
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS & OXIDIZING AGENTS.
Stability Condition to Avoid:HIGH TEMPS & IGNITION SOURCES.
Hazardous Decomposition Products:BY HEAT: IRRITATING & ACRID FUMES.
Conditions to Avoid Polymerization:HEAT & DIRECT SUNLIGHT.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS. UN1866
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:METHYL ALCOHOL, WOOD ALCOHOL, MX0480
CAGE:DO242
CAGE:DO242
CAGE:0GDF9
============= Composition/Information on Ingredients =============
Ingred Name:ING 10: (609) 354-9200. FOLLOWING EM SCIENCE SPILL-X
ABSORBENT IS RECOMMENDED FOR THIS PRODUCT: SX0863 SOLVENT (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11: SPILL TREATMENT KIT.
RTECS #:9999999ZZ
Ingred Name:RESP PROT:(NEGATIVE PRESSURE TYPE) UNDER SPECIFIED
CONDITIONS (SEE YOUR SAFETY EQUIPMENT SUPPLIER). ENGINEERING (ING
14)
RTECS #:9999999ZZ
Ingred Name:ING 13: &/OR ADMINISTRATIVE CONTROLS SHOULD BE IMPLEMENTED
TO REDUCE EXPOSURE.
RTECS #:9999999ZZ
Ingred Name:ING 9: ADDITIONAL INFO ON SPILL-X PRODUCTS CAN BE PROVIDED
THROUGH THE EM SCIENCE TECHNICAL SERVICE DEPARTMENT (ING 11)
RTECS #:9999999ZZ
Ingred Name:METHANOL (SARA 313) (CERCLA)
CAS:67-56-1
RTECS #:PC1400000
Fraction by Wt: 100%
OSHA PEL:200 PPM, S
ACGIH TLV:200 PPM; 250 STEL, S
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:SUPDAT: AT TYPICAL ELEVATED TEMP PROCESS CONDITIONS,
ESPECIALLY IN PROCESS OPERATING UNDER VACUUM IF SUBJECTED (ING 3)
RTECS #:9999999ZZ
Ingred Name:ING 2: TO SUDDEN INGRESS OF AIR OR OUTSIDE PROCESS
EQUIPMENT OPERATING UNDER ELEVATED PRESSURE IF SUDDEN ESCAPE (ING
4)
RTECS #:9999999ZZ
Ingred Name:ING 3: OF VAPORS OR MISTS TO THE ATMOSPHERE OCCURS.
RTECS #:9999999ZZ
Ingred Name:EFTS OF OVEREXP: IRRITATION. FETAL DEVELOPMENT
ABNORMALITIES & EFFECTS ON EMBRYO OR FETUS HAVE BEEN REPORTED (ING
6)
RTECS #:9999999ZZ
Ingred Name:ING 5: FROM PROLONGED EXPOSURE TO METHYL ALCOHOL IN LAB
TESTS INVOLVING PREGNANT RATS.
RTECS #:9999999ZZ
Ingred Name:SPILL PROC: DONE W/OUT RISK. TAKE UP & CONTAINERIZE FOR
PROPER DISPOSAL AS DESCRIBED UNDER DISPOSAL. COMPLY WITH (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7: FEDERAL, STATE & LOCAL REGS ON REPORTING RELEASES.
REFER TO REGULATORY INFO FOR REPORTABLE QUANTITY & (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8: OTHER REGULATORY DATA. EM SCIENCE RECOMMENDS SPILL-X
ABSORBENT AGENTS FOR VARIOUS TYPES OF SPILLS. (ING 10)
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50: (ORAL, RAT) 5628 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TOXIC BY INGESTION & INHALATION. CAN
BE TOXIC BY SKIN ABSORPTION. AFTER INGESTION OR INHALATION, INITIAL
SYMPTOMS MAY BE ONLY THAT OF MILD INTOXICATION, BUT MAY BECOME
SEVERE AFTER 12 TO 18 HOURS. AFF ECTS CENTRAL NERVOUS SYSTEM,
ESPECIALLYOPTIC NERVE. MARKED IMPAIRMENT OF VISION & ENLARGEMENT OF
THE (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: LIVER HAS BEEN REPORTED WITH CHRONIC
EXPOSURE. CHRONIC EXPOSURE MAY ALSO CAUSE DAMAGE TO KIDNEYS AND
CENTRAL NERVOUS SYSTEM. CAUSES DIZZINESS, NAUSEA, MUSCLE WEAKNESS,
NARCOSIS, RESPIRATORY FAILURE. INGESTION CAN PRODUCE BLINDNESS
(100 ML CAN BE FATAL). PROLONGED OR REPEATED SKIN CONTACT MAY CAUSE
(ING 5)
Medical Cond Aggravated by Exposure:SKIN CONDITIONS, EYE PROBLEMS OR
IMPAIRED LIVER OR KIDNEY FUNCTION.
======================= First Aid Measures =======================
First Aid:GET MED ASSISTANCE FOR ALL CASES OF OVEREXPOSURE. SKIN: WASH
THOROUGHLY W/SOAP & WATER. EYES: IMMED FLUSH THOROUGHLY W/WATER FOR
AT LEAST 15 MINUTES. INHAL: REMOVE TO FRESH AIR; GIVE ARTIFICIAL
RESPIR ATION IF BREATHING HAS STOPPED. INGEST:GET IMMED MED ATTN.
IF MED ATTN IS NOT IMMED AVAILABLE, INDUCE VOMITING. DO NOT INDUCE
VOMITING IF PATIENT IS UNCON. REMOVE CONTAMD CLTHG & WASH BEFORE
REUSE.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:52.0F,11.1C
Lower Limits:6.7%
Upper Limits:36.5%
Extinguishing Media:DRY CHEMICAL, "ALCOHOL" FOAM, CARBON DIOXIDE, WATER
MIST.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:DANGEROUS FIRE & EXPLOSIVE HAZARD. CLOSED
CNTNRS MAY EXPLODE UPON HEATING. VAPOR CAN TRAVEL DISTANCES TO
IGNITION SOURCE & FLASH BACK. HOT ORGANIC (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE THE AREA OF ALL UNNECESSARY
PERSONNEL. WEAR SUITABLE PROTECTIVE EQUIPMENT. ELIMINATE ANY
IGNITION SOURCES UNTIL AREA IS DETERMINED TO BE FREE FROM EXPLOSION
OR FIRE HAZARDS. CONTAIN THE RELEA SE & ELIMINATE ITS SOURCE, IF
THIS CAN BE (ING 7)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED. STORE IN A COOL
AREA AWAY FROM IGNITION SOURCES AND OXIDIZERS.
Other Precautions:DO NOT BREATHE VAPOR OR MIST. DO NOT GET IN EYES, ON
SKIN OR ON CLOTHING. ELECTRICALLY GROUND ALL EQUIPMENT WHEN
HANDLING THIS PRODUCT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF WORKPLACE EXPOSURE LIMIT(S) OF PRODUCT OR ANY
COMPONENT IS EXCEEDED, A NIOSH APPROVED AIR SUPPLIED RESPIRATOR IS
ADVISED IN ABSENCE OF PROPER ENVIRONMENTAL CONTROL. OSHA REGS ALSO
PERMIT OTHER NIOS H APPROVED RESPIRATORS (ING 13)
Ventilation:MATERIAL SHOULD BE HANDLED OR TRANSFERRED IN AN APPROVED
FUME HOOD OR WITH ADEQUATE VENTILATION.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. DO NOT TAKE
INTERNALLY.
Supplemental Safety and Health
EXPLO HAZ: CHEMICAL VAPORS/MISTS ARE SUSCEPTIBLE TO SUDDEN SPONTANEOUS
COMBUSTION WHEN MIXED W/AIR. IGNITION MAY OCCUR AT TEMPS BELOW
PUBLISHED AUTOIGNITION OR IGNITION TEMPS. IGNITION TEMPS DECREASE
W/INCREASING VAPOR VOLUME & VAPOR/AIR CONTACT TIME & ARE INFLUENCED
BY PRESSURE CHANGES. IGNITION MAY OCCUR (ING 2)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:148F,65C
Melt/Freeze Pt:M.P/F.P Text:-144F,-98C
Vapor Pres:97 @ 20C
Vapor Density:1.1
Spec Gravity:0.791 (H*2O=1)
Evaporation Rate & Reference:5.91 (BUAC=1)
Solubility in Water:MISCIBLE
Appearance and Odor:COLORLESS LIQUID; CHARACTERISTIC ALCOHOLIC ODOR.
Percent Volatiles by Volume:99.9+
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS, OXIDIZERS, REACTIVE METALS.
Stability Condition to Avoid:HEAT; CONTACT WITH IGNITION SOURCE.
Hazardous Decomposition Products:CO*X, FORMALDEHYDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATION, FUELS BLENDING OR RECYCLE. CONTACT
YOUR LOCAL PERMITTED WASTE DISPOSAL SITE (TSD) FOR PERMISSIBLE
TREATMENT SITES. ALWAYS CONTACT (TSD) TO ASSURE COMPLIANCE WITH ALL
CURRENT LOCAL, STATE & FEDERAL REGS. EPA WASTE NUMBERS: U154,
D001.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MAGNETIC BLACK POWDER, M114L/MSW202
CAGE:94514
CAGE:94514
============= Composition/Information on Ingredients =============
Ingred Name:STEEL MFG CHEMICALS; (ANCOR & ANCOR STEEL FE POWDER)
CAS:65997-19-5
OSHA PEL:15 MG/M3 (MFR)
ACGIH TLV:10 MG/M3 (MFR)
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:BRONCHITIS, EYE IRRITATION.
CHRONIC:SIDEROSIS, CONJUNCTIVITIS.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:EYE IRRITATION.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD IMMEDIATELY . SKIN:FLUSH W/COPIOUS AMOUNTS OF
WATER. CALL MD . INHAL:REMOVE TO FRESH AIR; IF NECESSARY, GET
MEDICAL HELP. EYES:FLUSH W/LARGE AMOUNTS OF WATER FOR AT LEAST 15
MINUTES; IF IRRITATION PERSISTS, SEEK MEDICAL HELP.
===================== Fire Fighting Measures =====================
Extinguishing Media:DRY CHEMICAL, DRY SAND.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . USE WATER FOG TO AVOID DUST FORMATION.
Unusual Fire/Explosion Hazard:POWDER OR DUST CAN POSE DUST EXPLOSION
HAZARD IF DISPERSED IN AIR.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL SPILL - WHERE POSSIBLE USE VACUUM
SWEEPER GENTLY TO PREVENT DUST FORMATION. DISCARD IN CLOSED
CONTAINER. ALWAYS USE RECOMMENDED PERSONAL PROTECTION DURING CLEAN
UP.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP IN CLOSED CONTAINERS. DO NOT
STORE NEAR STRONG OXIDIZERS.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED DUST RESPIRATOR WHERE
CONCENTRATION EXCEEDS LIMITS.
Ventilation:ADEQUATE TO MAINTAIN DUST BELOW LIMITS.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:5207F,2875C
Melt/Freeze Pt:M.P/F.P Text:2795F,1535C
Spec Gravity:>1 (H*2O=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:LIGHT TO DARK GRAY COLOR, FINE POWDER; NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
PURE OXYGEN OR OTHER STRONG OXIDIZERS.
Stability Condition to Avoid:AVOID DUST FORMATION.
Hazardous Decomposition Products:NONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF I/A/W LOCAL, STATE & FEDERAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:W7000 ACRYSHEEN ACRYLIC, W7000
CAGE:5G582
CAGE:5G582
============= Composition/Information on Ingredients =============
Ingred Name:PROPANOL, ALLYLOXY- (PROPYLENE GLYCOL), VP=0.1 MM/HG @ 68F
CAS:1331-17-5
RTECS #:UA4900000
Ingred Name:ETHYLENE GLYCOL (SARA III)
CAS:107-21-1
RTECS #:KW2975000
OSHA PEL:C 50 PPM
ACGIH TLV:C 50 PPM,VAPOR; 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:PROPIONIC ACID, 2-METHY-MONOESTER W/2,2,4- TRIMETHYL -1, 3-
PENTANEDIOL (TEXANOL)
CAS:25265-77-4
RTECS #:UF6000000
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL: MAY CAUSE HEADACHE & NAUSEA,
DIZZINESS. SKIN/EYE CONTACT: PRIMARILY AN IRRITANT. REDNESS/RASH ON
SKIN. INGEST:NAUSEA, DIZZINESS, HEADACHES.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:PROLONGED CONTACT W/MATERIAL MAY
CAUSE DERMATITIS.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. GET MD. EYES:FLUSH W/CLEAN WATER
FOR AT LEAST 15 MIN. GET MD. SKIN:REMOVE SATURATED CLTHING & WASH
SKIN W/SOAPY WATER THORO. GET MD. INGEST:INDUCE VOMIT W/1-OZ OF
SYRUP OF I PECAC FOLLOWED IN 5 MINUTES W/GLASS OF WATER. CALL MD.
===================== Fire Fighting Measures =====================
Lower Limits:0.6%
Extinguishing Media:FOAM, ALCOHOL FOAM, CO*2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . THIS IS A WATER-BASED PRODUCT. WILL NOT
SUPPORT COMBUSTION.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB SPILL W/ABSORBENT MATERIAL-SAWDUST,
SAND, CLAYS, ETC., & FLUSH SPILL AREA W/LOTS OF WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:PRODUCT IS STABLE UNDER NORMAL USE &
STORAGE CONDITIONS. KEEP OUT OF REACH OF CHILDREN. KEEP FROM
FREEZING.
Other Precautions:DO NOT TAKE INTERNALLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN DURING APPLICATION TO AVOID EXCESSIVE
INHAL OF VAPORS. OPEN WINDOWS & DOORS OR USE OTHER MEANS TO INSURE
FRESH AIR ENTRY D URING APPLICATION & DRYING.
Ventilation:PROVIDE ADEQ VENT AT ALL TIMES DURING HANDLING &
APPLICATION.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:OBSERVE STANDARD HYGIENIC PRACTICES.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Vapor Pres:ING 1,2
Vapor Density:>AIR
Spec Gravity:1.3
Evaporation Rate & Reference:SLOWER THAN ETHER.
Solubility in Water:DILUTABLE.
Appearance and Odor:WHITE PAINT & COLORS - SLIGHT AMMONIA SMELL.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS & ALKALIS & MATERIALS THAT REACT W/WATER.
Stability Condition to Avoid:DO NOT STORE IN HIGH TEMPERATURE AREAS.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:PLACE ALL HAZARDOUS WASTES, INCLUDING ABSORBENTS
USED FOR SPILLS, IN 55-GAL METAL DRUMS & DISPOSE IN APPROVED
DUMPSITE IN ACCORDANCE W/PRESCRIBED FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
=======================================================
Product ID: ELECTRICAL CONTACT CLEANER, 24379
Cage: 7K128
=======================================================
Contractor Summary
=======================================================
Cage: 7K128
Cage: 05972
=======================================================
Ingredients
=======================================================
Cas: 1717-00-6
RTECS #: KI0997000
GRAV:1.23. VP:10.02 PSIA. VAP DENS:4.1.
% Wt: 95-100
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
Ozone Depleting Chemical: 2
------------------------------
Cas: 124-38-9
RTECS #: FF6400000
% Wt: 3-5
OSHA PEL: 5000 PPM
ACGIH TLV: 5000 PPM;30000 STEL
------------------------------
& OTHER HEAT SOURCES COULD CAUSE CNTNR TO
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: CHLOROFLUOROCARBON (CFC) MATLS HAVE PRDCD SENSIT OF
MYOCARDIUM TO EPINEPHRINE IN LAB ANIMALS & COULD HAVE SIMILAR EFT IN
HUMANS. ADRENOMIMETICS (E.G., EPINEPHRINE) MAY BE CONTRAINDICATED EXCEPT FOR
LI FE-SUSTAINING USES IN HUMANS ACUTELY/CHRONICALLY EXPOS TO CFC'S (FP N).
IRRIT OF EYES, SKIN & UPPER (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: HLTH HAZ:RESP SYS. IN CONFINED AREA VAPS
IN HIGH CONC MAY CAUSE HDCH, NAUS/DIZZ. EXPOS MAY BE BY INHAL &/OR
SKIN/EYE CONT, DEPENDING ON CNDTNS OF USE. TO MIN EXPOS, FOLLOW RECS FOR
PROPER USE, VENT & PPE. HDCH, DIZZ, NAUS FROM EXCESSIVE EXPOS TO
VAPS/SPRAY MISTS. REDNESS & ITCH/BURNING SENSATION MAY INDICATE (SUPDAT)
Medical Cond Aggravated By Exposure: NONE GENERALLY RECOGNIZED.
First Aid: INGEST:NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. DO NOT
INDUCE VOMITING. GIVE SEVERAL GLASSES OF WATER. SEEK MEDICAL ATTENTION.
INHAL:REMOVE FROM EXPOSURE. RESTORE BREATHING. KEEP WARM & QUIET.
SKIN:WASH AFFECTED AREA THOROUGHLY W/SOAP & WATER. REMOVE CONTAMINATED
CLOTHING & LAUNDER BEFORE REUSE. EYES:FLUSH W/LARGE AMOUNTS OF WATER FOR
AT LEAST 15 MINUTES. GET MEDICAL ATTENTION.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: REMOVE ALL SOURCES OF IGNITION. MAINTAIN GOOD
VENTILATION. SOAK UP W/INERT ABSORBENT. STORE IN A CLOSED CONTAINER UNTIL
DISPOSAL.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DO NOT INCINERATE. DEPRESSURIZE CONTAINER. DISPOSE OF
I/A/W FEDERAL, STATE & LOCAL REGULATIONS REGARDING POLLUTION. EPA
HAZARDOUS WASTE NUMBER: F002 - HAZARDOUS WASTE PER 40 CFR 261.31.
Handling And Storage Precautions: STORE BELOW 100F. (CONTACT LOCTITE CUSTOMER
SERVICE 1-800-243-4874 FOR SHELF LIFE INFO). USE ONLY W/ADEQ VENT. AVOID
BREATHING VAPOR & SPRAY MIST.
Other Precautions: NO SMOKING IN AREA OF USE. DO NOT USE IN GEN VICIN OF ARC
WELDING, OPEN FLAMES/HOT SURFS. HEAT &/OR UV RADIA MAY CAUSE FORMATION OF
CHLORIDES, FLUORIDES/PHOSGENE (FP N). AVOID CONT W/SKIN & EYES. CONT ENTS
UNDER PRESS. DO NOT (SUPP DATA)
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: PMCC
Flash Point Text: >200F,>93C
Lower Limits: 7.5%
Upper Limits: 17.7%
Extinguishing Media: CARBON DIOXIDE, FOAM, DRY CHEMICAL.
Fire Fighting Procedures: WEAR NIOSH APPRVD PRESS DEMAND SCBA & FULL PROT
EQUIP (FP N). WATER SPRAY MAY BE INEFT. IF WATER IS USED, FOG NOZZ ARE PREF.
WATER MAY BE USED TO COOL (SUPDAT)
Unusual Fire/Explosion Hazard: THERMAL DECOMPOSITION PRODUCTS MAY INCLUDE
FLUORIDES, CHLORIDES & PHOSGENE (FP N). CLOSED CONTAINERS MAY EXPLODE
WHEN EXPOSED TO EXTREME HEAT.
=======================================================
Control Measures
=======================================================
Respiratory Protection: IF PERSONAL EXPOSURE CANNOT BE CONTROLLED BELOW
APPLICABLE LIMITS BY VENTILATION WEAR A PROPERLY FITTED NIOSH APPROVED
ORGANIC/PARTICULATE RESPIRATOR FOR PROTECTION AGAINST MATERIALS IN
INGREDIENTS SE CTION.
Ventilation: LOC EXHST PREF. GEN EXHST ACCEPT IF EXPOS TO INGS IS MAINTAINED
BELOW APPLIC EXPOS LIMS. REFER TO OSHA STDS (SUPP DATA)
Other Protective Equipment: EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET ANSI
DESIGN CRITERIA (FP N).
Work Hygienic Practices: WASH HANDS AFTER USING.
Supplemental Safety and Health: FIRE FIGHT PROC:CNTNRS TO PVNT PRESS BUILD-UP
& POSS AUTOIGNIT/EXPLO WHEN EXPOS TO EXTREME HEAT. HAZ DECOMP
PROD:CARBONYL HALIDES. EFTS OF OVEREXP:EYE/EXCESSIVE SKIN EXPOS. TARGET ORG
& OTHER HLTH EFT S:CARBON DIOXIDE:CNS, DEVELOPMENTAL. VENT:1910.94,
1910.107, 1910.108. OTHER PREC:PUNCTURE, INCIN/EXPOS TO TEMP
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: <90F,<32C
Vapor Pres: SEE ING 1
Vapor Density: SEE ING 1
Spec Gravity: SEE ING 1
Evaporation Rate & Reference: FASTER THAN ETHER
Solubility in Water: SEE INGREDIENT 1
Appearance and Odor: CLEAR LIQUID; ETHEREAL & FAINTLY SWEETISH ODOR.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: STRONG ACIDS & ALKALIS, REACTIVE METALS, STRONG OXIDIZING
AGENTS, SOME DESICCANTS.
Hazardous Decomposition Products: CHLORIDES, FLUORIDES & PHOSGENE (FP N). IRRIT
ORG VAPS, OXIDES OF CARBON, HYDROCHLORIC ACID, HYDROFLUORIC ACID, (SUPDAT)
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
Other Information: VOLATILE ORGANIC COMPOUNDS (EPA METHOD 24): FEDERAL:0.0%;
0.0 G/L (MATERIAL). SOME STATES:100%; 1230 G/L.
=======================================================
HAZCOM Label
=======================================================
Product ID: ELECTRICAL CONTACT CLEANER, 24379
Cage: 7K128
Company Name: LOCTITE CORP
Street: 705 N MT RD
Zipcode: 06111
Label Required IND: Y
Date Of Label Review: 01/14/1998
Status Code: C
Label Date: 01/14/1998
Origination Code: G
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Slight
Fire Hazard: Slight
Reactivity Hazard: Slight
Hazard And Precautions: DECOMPOSITION PRODUCTS MAY BE HAZARDOUS.
ACUTE:INHALATION OF VAPORS MAY CONTRIBUTE TO THE OCCURRENCE OF IRREGULAR
HEARTBEAT (FP N). IRRITATION OF EYES, SKIN AND UPPER RESPIRATORY SYSTEM. MAY
CAUSE HEA DACHE, NAUSEA, DIZZINESS. REDNESS AND ITCHING OF BURNING SENSATION
MAY INDICATE EYE OR EXCESSIVE SKIN EXPOSURE. CHRONIC:NONE LISTED BY
MANUFACTURER. TARGET ORGANS:CENTRAL NERVOUS SYSTEM, DEVELOPMENTAL .
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:62-9902 ELECTROPHOTOGRAPHIC TONER M975/985/995/995R
Preparer's Name:KENNETH W PINTER
CAGE:17638
CAGE:17638
============= Composition/Information on Ingredients =============
Ingred Name:COLUMBIA CARBON, CARBON BLACK, LAMPBLACK (SUSPECTED HUMAN
CARCINOGEN BY ACGIH), BLACK PEARLS
CAS:1333-86-4
RTECS #:FF5800000
Other REC Limits:3.5 MG/CUM (NIOSH)
OSHA PEL:3.5 MG/CUM
ACGIH TLV:3.5 MG/CUM
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT): >5 G/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: IF DUSTY CONDITIONS OCCUR,
MAY CAUSE RESPIRATORY IRRITATION.
Explanation of Carcinogenicity:SEE INGREDIENTS.
Effects of Overexposure:NONE KNOWN OR EXPECTED UNDER NORMAL HANDLING &
USE CONDITIONS.
======================= First Aid Measures =======================
First Aid:INGESTION: IMMEDIATELY DRINK WATER TO DILUTE. EYE: FLUSH
W/WATER FOR 15 MINUTES. SKIN: WASH W/SOAP & WATER. INHALATION:
IMMEDIATELY REMOVE VICTIM TO FRESH AIR. OBTAIN MEDICAL ATTENTION IN
ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER FOG/ALCOHOL FOAM/CO2/DRY CHEMICAL
Fire Fighting Procedures:WATER SPRAY SHOULD BE USED TO COOL FIRE
EXPOSED CONTAINERS. USE NIOSH/MSHA APPROVED POSITIVE PRESSURE SCBA
WHEN ANY MATERIAL IS INVOLVED IN A FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR NIOSH/MSHA APPROVED DUST RESPIRATOR. WEAR
OCCUR. CLEAN UP & PLACE IN AN APPROPRIATE CONTAINER & SEAL.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS CLOSED, STORE IN
COOL/DRY PLACE. DON'T STORE NEAR IGNITION SOURCES. DON'T TAKE
INTERNALLY. AVOID CONTACT W/EYES/SKIN/CLOTHING.
Other Precautions:AVOID INHALATION OF DUST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AS REQUIRED
Ventilation:MECHANICAL (GENERAL)
Other Protective Equipment:AS REQUIRED
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Spec Gravity:1.1
Solubility in Water:INSOLUBLE
Appearance and Odor:BLACK FINE POWDER, W/FAINT ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:EXCESS HEAT
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF CONTAMINATED PRODUCT, EMPTY
CONTAINERS & MATERIALS USED IN CLEANING UP SPILLS OR LEAKS IN A
MANNER APPROVED FOR THIS MATERIAL. CONSULT APPROPRIATE FEDERAL,
STATE & LOCAL REGULATORY AGENCIES TO ASCERTAIN PROPER DISPOSAL
PROCEDURES.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:23F4962
CAGE:JO842
CAGE:24446
CAGE:JO842
============= Composition/Information on Ingredients =============
Ingred Name:POLYCHLORINATED BIPHENYLS (PCBS) (SARA III)
CAS:1336-36-3
RTECS #:TQ1350000
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Effects of Overexposure:ABSORBED THRU SKIN,LUNGS,INTESTINE.CAUSES
CANCER,LIVER,KIDNEY,STOMACH,EYE,HEARING DISORDER(SUP DATA)
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/WATER IMMEDIATELY.SKIN:WASH W/SOAP
IMMEDIATELY.INHAL:REMOVE TO FRESH AIR,GIVE ART.RESPIR. AS
NEEDED.INGEST:GET MEDICAL ATTN.GIVE LARGE QTY OF SALT WATER,INDUCE
VOMITING,BUT DO NOT MAKE UN CONSCIOUS PERSON VOMIT.
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT & DIKES TO PREVENT
RUNOFF.ISOLATE & NOTIFY PROPER AUTHORITIES.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE MUST FOLLOW RCRA REQUIREMENTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SUPPLIED AIR W/FULL FACEPIECE,HELMET OR HOOD
Ventilation:LOCAL EXHAUST
Other Protective Equipment:FULL CLOTHING TO PREVENT SKIN CONTACT
Supplemental Safety and Health
OVEREXPOS:CAN CAUSE FORMATION OF CYSTS,CAUSES STILLBIRTHS.IRRITATES
EYES,NOSE THROAT.
================== Physical/Chemical Properties ==================
HCC:Z3
Appearance and Odor:LIGHT STRAW-COLORED LIQUID AROMATIC ODOR
================= Stability and Reactivity Data =================
STRONG OXIDIZERS
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-GENERALLY HIGH
TEMPERATURE INCINERATION.ONLY APPROVED DISPOSAL OPERATOR PERMITTED.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:39816-0 HEXAMETHYLENETETRAMINE 99+% ACS REAGENT
CAGE:21076
CAGE:60928
CAGE:63181
CAGE:21076
============= Composition/Information on Ingredients =============
Ingred Name:HEXAMETHYLENETETRAMINE
CAS:100-97-0
RTECS #:MN4725000
Fraction by Wt: 99%
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(MOUSE): 569 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:HARMFUL IF INGESTED, INHALED/ABSORBED
THROUGH SKIN. EYES: IRRITATION. SKIN: IRRITATION, SENSITIZATION
PRODUCING URTICARIA/DERMATITIS & ALLERGIC REACTIONS. INHALATION:
IRRITATING TO MUCOUS MEMBRANES & UPPER RESPIRATORY TRACT &
ALLERGIC RESPIRATORY REACTIONS. INGESTION: INFLAMMATORY LESIONS IN
THE RENAL TUBULES.(SEE SUPP
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, ASTHMA LIKE CONDITION, VOMITING,
DIARRHEA, ABDOMINAL PAIN.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/COPIOUS AMOUNTS OF WATER FOR 15 MINS. SKIN:
WASH W/SOAP & COPIOUS AMOUNTS OF WATER. INHALATION: REMOVE TO FRESH
AIR. GIVE CPR/OXYGEN IF NEEDED. INGESTION: WASH OUT MOUTH W/WATER
IF CONSC IOUS. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:482F
Extinguishing Media:WATER SPRAY, CO2, DRY CHEMICAL POWDER/APPROPRIATE
FOAM.
Fire Fighting Procedures:WEAR SCBA & PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:FLAMMABLE SOLID. EMITS TOXIC FUMES UNDER
FIRE CONDITIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE AREA. WEAR SCBA, RUBBER BOOTS & HEAVY
AVOID RAISING DUST. VENTILATE AREA & WASH SITE AFTER MATERIAL
PICKUP IS COMPLETE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL DRY PLACE. KEEP AWAY
FROM HEAT, SPARKS & OPEN FLAME. KEEP TIGHTLY CLOSED. HYGROSCOPIC.
Other Precautions:AVOID PROLONGED/REPEATED EXPOSURE. DON'T GET IN EYES,
SKIN/CLOTHING. AVOID INHALATION. AVOID CONTACT W/ACID.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR APPROPRIATE NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:CHEMICAL FUME HOOD.
Other Protective Equipment:PROTECTIVE CLOTHING, SAFETY SHOWER & EYE
BATH.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
HLTH HZRD CONT'D: RENAL PELVIS & URINARY BLADDER, ALBUMIN/BLOOD IN THE
URINE. MAY CAUSE CANCER & HERITABLE GENETIC DAMAGE.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:536F
Appearance and Odor:WHITE CRYSTALS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG ACIDS.
Stability Condition to Avoid:MOISTURE.
Hazardous Decomposition Products:COMBUSTION: CO, CO2, NITROGEN OXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISSOLVE/MIX W/A COMBUSTIBLE SOLVENT & BURN IN A
CHEMICAL INCINERATOR EQUIPPED W/AN AFTERBURNER & SCRUBBER,
IAW/FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ROYCO 783
Resp. Party Other MSDS Num.:750,112
Preparer's Name:NOT PROVIDED.
CAGE:07950
Contract Num:SP0450-00-M-C041
CAGE:07950
============= Composition/Information on Ingredients =============
Ingred Name:HYDROTREATED LIGHT NAPHTHENIC DISTILLATE,CAS# 64742-53-6
CAS:64742-53-6
RTECS #:PY8036000
Minumum % Wt:10.
Maxumum % Wt:80.
Other REC Limits:NOT PROVIDED.
OSHA PEL:NOT PROVIDED.
ACGIH TLV:NOT PROVIDED.
Ingred Name:SOLVENT REFINED, HYDROTREATED MIDDLE DISTILLATE, CAS #
64742-46-7
CAS:64742-46-7
RTECS #:JN9379645
Minumum % Wt:0.
Maxumum % Wt:70.
Other REC Limits:NOT PROVIDED.
OSHA PEL:NOT PROVIDED.
ACGIH TLV:NOT PROVIDED.
Ingred Name:ADDITIVE CONTAINING BARIUM DINONYLNAPHTHALENESULFONATE,CAS#
25619-56-1
CAS:25619-56-1
Minumum % Wt:3.
Maxumum % Wt:8.
Other REC Limits:NOT PROVIDED.
OSHA PEL:NOT PROVIDED.
ACGIH TLV:NOT PROVIDED.
Ingred Name:MINOR ADDITIVES
Minumum % Wt:12.
Maxumum % Wt:15.
Other REC Limits:NOT PROVIDED.
OSHA PEL:NOT PROVIDED.
ACGIH TLV:NOT PROVIDED.
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL RAT) IS NOT AVAILABLE
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE CONTACT: BASED ON PRESENCE OF
COMPONENT 3, THIS PRODUCT IS IRRITATING TO THE EYES. SKIN CONTACT:
BASED ON PRESENCE OF COMPONENT 3, THIS PRODUCT MAY BE IRRITATING TO
THE SKIN. PROLONGED/REPEATED LI QUID CONTACT CAN RESULT IN
DEFATTING AND DRYING OF THE SKIN WHICH MAY RESULT IN SKIN
IRRITATION AND DERMATITIS.INHALATION: INHALATION OF VAPORS
(GENERATED AT HIGH TEMPERATURES ONLY) OR OIL MIST MAY BE MILDLY
IRRITATING TO THE NOSE, THROAT, AND RESPIRATORY TRACT. INGESTION:
INGESTION OF THIS PRODUCT MAY RESULT IN VOMITING; ASPIRATION OF
VOMITUS INTO THE LUNGS MUST BE AVOIDED AS EVEN SMALL QUANTIT IES
MAY RESULT IN ASPIRATION PNEUMONITIS
Explanation of Carcinogenicity:THIS PRODUCT DOES NOT CONTAIN ANY
CARCINOGENS AS IDENTIFIED BY IARC, NTP, OR OSHA.
Effects of Overexposure:IRRITATION AS NOTED ABOVE. ASPIRATION
PNEUMONITIS MAY BE EVIDENCED BY COUGHING, LABORED BREATHING AND
CYANOSIS (BLUISH SKIN): IN SEVERE CASES DEATH MAY OCCUR.
Medical Cond Aggravated by Exposure:PREEXISTING EYE, SKIN AND
RESPIRATORY DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS
PRODUCT.
======================= First Aid Measures =======================
First Aid:EYE CONTACT: IMMEDIATELY FLUSH EYES WITH PLENTY OF WATER FOR
AT LEAST 15 MINUTES WHILE HOLDING EYELIDS OPEN. GET MEDICAL
ATTENTION. SKIN CONTACT: REMOVE CONTAMINATED CLOTHING OR SHOES.
WIPE EXCESS FRO M SKIN AND FLUSH WITH PLENTY OF WATER FOR AT LEAST
15 MINUTES FOLLOWED BY WASHING WITH SOAP AND WATER. INHALATION:
REMOVE VICTIM TO FRESH AIR AND PROVIDE OXYGEN IF BREATHING IS
DIFFICULT. GIVE ARTIFIC IAL RESPIRATION IF NOT BREATHING. GET
MEDICAL ATTENTION. DO NOT INDUCE VOMITING. IF VOMITING OCCURS
SPONTANEOUSLY, KEEP HEAD BELOW HIPS TO PREVENT ASPIRATION OF LIQUID
INTO THE LUNGS. GET MEDICAL ATTE NTION.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:>93.3C, 200.F
Lower Limits:NOT AVAILABL
Upper Limits:NOT AVAILABL
Extinguishing Media:USE WATER FOG, FOAM, DRY CHEMICAL OR CO2. DO NOT
USE A DIRECT STREAM OF WATER. PRODUCT WILL FLOAT AND CAN BE
REIGNITED ON SURFACE OF WATER.
Fire Fighting Procedures:MATERIAL WILL NOT BURN UNLESS PREHEATED. DO
NOT ENTER CONFINED FIRE SPACE WITHOUT FULL BUNKER GEAR (HELMET WITH
POSITIVE PRESSURE NIOSH APPROVED SELF-CONTAINED BREATHNG
APPARATUS. COOL FIRE-EXPOSED CONTAINERS WITH WATER.
Unusual Fire/Explosion Hazard:NOT PROVIDED.
================== Accidental Release Measures ==================
Spill Release Procedures:LARGE SPILLS: WEAR RESPIRATORY AND PROTECTIVE
CLOTHING AS APPROPRIATE. SHUT OFF SOURCE OF LEAK IF SAFE TO DO SO.
DIKE AND CONTAIN. REMOVE WITH VACUUM TRUCK OR PUMPTO
STORAGE/SALVAGE VESSELS. SOAK UP RESIDUE WITH AN ABSORBENT SUCH AS
CLAY, SAND OR OTHER SUITABLE MATERIAL: DISPOSE OF PROPERLY. FLUSH
AREA WITH WATER TO REMOVE TRACE RESIDUE. SMALL SPILLS: TAKE UP WITH
ABSORBENT. DISPOSE OF PROPERLY.
Neutralizing Agent:NOT RELEVANT.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE WITH
ADEQUATE VENTILATION. KEEP AWAY FROM OPEN FLAMES AND HIGH
TEMPERATURES.
Other Precautions:AVOID EYE AND SKIN CONTACT. WASH WITH SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING, APPLYING COSMETICS OR USING
TOILET FACILITIES. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
CONTAMINATED LEATHER A RTICLES INCLUDING SHOES CANNOT BE
DECONTAMINATED AND SHOULD BE DESTROYED TO PREVENT REUSE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AVOID BREATHING VAPORS AND MIST. IF EXPOSURE
MAY OR DOES EXCEED OCCUPATIONAL EXPOSURE LIMITS, USE A
NIOSH-APPROVED RESPIRATOR TO PREVENT OVEREXPOSURE. IN ACCORD WITH
29 CFR 1910.134 USE EITHER A FULL -FACE, ATMOSPHERE-SUPPLYING
RESPIRATOR OR AIR-PURIFYING RESPIRATOR FOR ORGANIC VAPORS AND
PARTICULATES.
Ventilation:USE VENTILATION AS REQUIRED TO CONTROL VAPOR
CONCENTRATIONS.
Other Protective Equipment:EYE WASH FOUNTAIN AND SAFETY SHOWERS SHOULD
BE AVAILABLE FOR EMERGENCY USE.
Work Hygienic Practices:AVOID PROLONGED OR REPEATED CONTACT WITH SKIN.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:V6
NRC/State Lic Num:NOT RELEVANT.
Boiling Pt:B.P. Text:NOT AVAILABLE.
Melt/Freeze Pt:M.P/F.P Text:NOT AVAILABLE.
Decomp Temp:Decomp Text:NOT PROVIDED.
Vapor Pres:NOT AVAILABLE.
Vapor Density:NOT AVAILA
Spec Gravity:0.85 APPROX.
Viscosity:NOT PROVIDED.
Evaporation Rate & Reference:NOT PROVIDED.
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR LIQUID
Percent Volatiles by Volume:NOT PROVIDED
Corrosion Rate:NOT PROVIDED.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:AVOID HEAT AND OPEN FLAMES.
Hazardous Decomposition Products:A COMPLEX MIXTURE OF AIRBORNE SOLID,
LIQUID, PARTICULATES AND GASES WILL EVOLVE WHEN MATERIAL UNDERGOES
PYROLYSIS OR COMBUSTION. CARBON MONOXIDE AND OTHER UNIDENTIFIED
ORGANIC COMPOUNDS MAY BE FORMED.
=================== Toxicological Information===================
Toxicological Information:NOT PROVIDED.
===================== Ecological Information =====================
Ecological:NOT PROVIDED.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTAINS BARIUM AT > 100 MG/L. UNDER EPA-RCRA
(40 CFR 261.24), A WASTE CONTAING BARIUM IS HAZARDOUS (WASTE NUMBER
D005), IF IT EXHIBIT THE CHARACTERISTIC OF TOXICITY BASED ON THE
EXTRACTED CONCENTRATI ON OF BARIUM AS SHOWN BY TOXICITY
CHARACTERISTIC LEACHING PROCEDURE (TCLP). MATERIAL MAY BE RECYCLED
. CHECK LOCAL AND STATE REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:DEPARTMENT OF TRANSPORTATION CLASSIFICATION: NOT
HAZARDOUS BY D.O.T. REGULATIONS.
===================== Regulatory Information =====================
SARA Title III Information:UNDER EPA-CWA, THIS PRODUCT IS CONSIDERED AN
OIL AND CONTAINS A COMPONENT DESIGNATED AS A HAZARDOUS SUBSTANCE
UNDER SECTION 311.SPILLS INTO OR LEADING TO SURFACE WATER THAT
CAUSE A SHEEN MUST BE REP ORTED TO THE NATIONAL RESPONSE CENTER,
800-424-8802. UNDER SARA TITLE III, SECTION 313, THIS PRODUCT
CONTAINS BARIUM COMPOUNDS.
Federal Regulatory Information:THE COMPONENTS OF THIS PRODUCT ARE
LISTED ON THE EPA/TSCA INVENTORY OF CHEMICAL SUBSTANCES.
State Regulatory Information:NOT PROVIDED.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:T324-500 23590 TOLUENE
CAGE:1B464
CAGE:1B464
============= Composition/Information on Ingredients =============
Ingred Name:TOLUENE (IARC CARC- GROUP 3) *96-4*
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: >99%
Other REC Limits:375 MG/CUM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION, RESULTING IN CORNEAL
INJURY. SKIN: PROLONGED/REPEATED CONTACT CAUSES
IRRITATION/DERMATITIS. INGESTION: IRRITATION OF DIGESTIVE TRACT.
ASPIRATION OF MATERIAL INTO LUNGS CAUSES CHEMICA L
PNEUMONITIS/FATAL. INHALATION: CNS EFFECTS, RESPIRATORY TRACT
IRRITANT, CARDIAC ARREST/DEATH. KIDNEY/LIVER DAMAGE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, HEADACHE, DIZZINESS,
UNCONSCIOUSNESS, COMA, HEART DISTURBANCES
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/PLENTY OF WATER FOR 15 MINS. DON'T ALLOW VICTIM
TO RUB/KEEP EYES CLOSED. SKIN: FLUSH W/PLENTY OF SOAP & WATER FOR
15 MINS. INGESTION: DON'T INDUCE VOMITING. IF CONSCIOUS & ALERT,
GIVE 2- 4 CUPFULS OF MILK/WATER. ASPIRATION HAZARD. INHALATION:
REMOVE TO FRESH AIR IMMEDIATELY. GIVE CPR/OXYGEN IF NECESSARY.
OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:40F
Lower Limits:1.1
Upper Limits:7.1
Extinguishing Media:DRY CHEMICAL, CO2/ALCOHOL-RESISTANT FOAM
Fire Fighting Procedures:WEAR A SCBA IN PRESSURE-DEMAND, MSHA/NIOSH
APPROVED & FULL PROTECTIVE GEAR. DIKE/COLLECT WATER USED. USE WATER
SPRAY TO KEEP FIRE-EXPOSED CONTAINERS COOL.
Unusual Fire/Explosion Hazard:CONTAINERS CAN BUILD UP PRESSURE IF
EXPOSED TO HEAT/FIRE. VAPORS CAN TRAVEL TO IGNITION SOURCES, FLASH
BACK/FORM EXPLOSIVE MIXTURES AT TEMPS >THE FLASHPOINT.
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PROTECTIVE EQUIPMENT. AVOID RUNOFF
INTO STORM SEWERS & DITCHES/WATERWAYS. SCOOP UP W/A NONSPARKING
TOOL, THEN PLACE INTO A SUITABLE CONTAINER FOR DISPOSAL. USE WATER
SPRAY TO DISPERSE THE G AS/VAPOR. REMOVE ALL IGNITION SOURCES.
ABSORB LEAK
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY, WELL-VENTILATED
AREA AWAY FROM INCOMPATIBLE SUBSTANCES. KEEP AWAY FROM SOURCES OF
IGNITION.
Other Precautions:EMPTY CONTAINERS RETAIN PRODUCT RESIDUE & CAN BE
DANGEROUS. DON'T
PRESSURIZE/CUT/WELD/BRAZE/SOLDER/DRILL/GRIND/EXPOSE CONTAINERS TO
HEAT/SPARKS/OPEN FLAMES. DON'T GET ON SKIN/IN EYES. DON'T
INGEST/INH ALE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:ALWAYS USE A NIOSH-APPROVED RESPIRATOR WHEN
NECESSARY.
Ventilation:GENERAL/LOCAL EXHAUST TO KEEP AIRBORNE CONCENTRATIONS BELOW
THE PERMISSIBLE EXPOSURE LIMITS.
Other Protective Equipment:PROTECTIVE CLOTHING
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
WATER RUNOFF CAN CAUSE ENVIRONMENTAL DAMAGE. MATERIAL IS LIGHTER THAN
WATER & A FIRE MAY SPREAD BY THE USE OF WATER. HEALTH HAZ CONT'D:
OVEREXPOSURE MAY CAUSE CARDIAC SENSITIZATION & SEVERE HEART ABNO
RMALITIES. INCOMPATIBILITIES CONT'D: NITRIC ACID & SULFURIC
ACID/SILVER PERCHLORATE/STRONG OXIDIZERS.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:232F
Melt/Freeze Pt:M.P/F.P Text:-139F
Vapor Pres:10
Vapor Density:3.1
Spec Gravity:0.9
Evaporation Rate & Reference:(BUTYL ACETATE=1): 2.4
Solubility in Water:0.6 MG/L
Appearance and Odor:COLORLESS LIQUID W/AROMATIC, SWEET ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
BROMINE TRIFLUORIDE/1,3-DICHLORO-5,5-DIMETHYL-2,4-IMIDAZOLIDIDIONE,
DINITROGEN TETROXIDE/CONCENTRATED NITRIC ACID (SUPP)
Stability Condition to Avoid:EXCESSIVE HEAT & OTHER IGNITION SOURCES
Hazardous Decomposition Products:CO, CO2
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TIN, 95081
CAGE:JO626
CAGE:09KS0
CAGE:JO626
============= Composition/Information on Ingredients =============
Ingred Name:TIN
CAS:7440-31-5
RTECS #:XP7320000
Fraction by Wt: 0.01-1%
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3
Ingred Name:HYDROCHLORIC ACID (SARA 302/313) (CERCLA)
CAS:7647-01-0
RTECS #:MW4025000
Fraction by Wt: 2%
OSHA PEL:5 PPM, C
ACGIH TLV:5 PPM, C
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 80%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:IRRITATION OF MUCOUS MEMBRANES.
SKIN/EYE IRRITATION OR INFLAMMATION. SKIN ABSORPTION.
TIN:EXPERIMENTAL TUMORIGEN; HYDROCHLORIC ACID:POISON.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE.
======================= First Aid Measures =======================
First Aid:SEEK MEDICAL ASSISTANCE FOR FURTHER ASSISTANCE. EYES:FLUSH
W/WATER FOR AT LEAST 15 MINUTES. SKIN:FLUSH W/WATER FOR 15 MINUTES.
WASH CONTAMINATED CLOTHING BEFORE RE-USE. INHAL:REMOVE TO FRESH
AIR. INGE ST:DO NOT INDUCE VOMITING. GIVE WATER OR MILK.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER OR CO*2.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:TAKE UP W/INERT, ABSORBENT MATERIAL.
CONTAINERIZE FOR DISPOSAL. FLUSH SPILL AREA W/WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY PLACE. KEEP
CONTAINER SEALED.
Other Precautions:NO OTHER SPECIAL PRECAUTIONS OR HAZARDS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED RESPIRATOR, WHEN NEEDED.
Ventilation:NONE REQUIRED. LOCAL EXHAUST, WHEN NEEDED.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . LAB COAT.
Work Hygienic Practices:USUAL.
Supplemental Safety and Health
EYE PROT:& FULL LENGTH FACESHIELD .
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Spec Gravity:1 (H*2O=1)
Evaporation Rate & Reference:SAME AS H*2O=1
Solubility in Water:SOLUBLE
Appearance and Odor:CLEAR, COLORLESS SOLUTION; NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG BASES OR STRONG REDUCING AGENTS.
Stability Condition to Avoid:EXCESSIVE HEAT OR EXTREME COLD.
Hazardous Decomposition Products:NO*X.
==================== Disposal Considerations ====================
Waste Disposal Methods:CORROSIVE WASTE I/A/W ALL FEDERAL, STATE & LOCAL
ENVIRONMENTAL REGULATIONS.
| 1 | gloves_mandatory |
=======================================================
Product ID: VW60H
Cage: EO631
=======================================================
Contractor Summary
=======================================================
Cage: EO631
=======================================================
Ingredients
=======================================================
Cas: 100-37-8
RTECS #: KK5075000
% Wt: 8
OSHA PEL: 10 PPM, S
ACGIH TLV: 2 PPM, S
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: EYES:CAN CAUSE INTENSE PAIN WHEN IN DIRECT CONTACT.
SKIN:CAN CAUSE IRRITATION FROM DIRECT CONTACT.
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: IRRITATION OF SKIN OR EYES.
Medical Cond Aggravated By Exposure: NONE ESTABLISHED.
First Aid: INGEST:CALL MD IMMEDIATELY (FP N). INHAL:REMOVE TO FRESH AIR.
SUPPORT BREATHING (GIVE O*2/ARTF RESP) (FP N). EYES:IMMEDIATELY FLUSH
W/POTABLE WATER FOR A MINIMUM OF 15 MINUTES, SEEK ASSISTANCE FROM MD(FP N).
SKIN:FLUSH W/WATER FOR AT LEAST 15 MINUTES.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: SEPARATE FOR PROPER DISPOSAL.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: BURY IN LANDFILL OR BURN IN ADEQUATE INCINERATOR IN
ACCORD WITH APPLICABLE FEDERAL, STATE & LOCAL LAWS.
Handling And Storage Precautions: AVOID TEMPERATURES IN EXCESS OF 250F.
Other Precautions: NONE KNOWN.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: >450F,>232C
Extinguishing Media: STANDARD A TYPE EXTINGUISHER.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N).
=======================================================
Control Measures
=======================================================
Respiratory Protection: NIOSH APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF
CONCERN (FP N). STORE & HANDLE IN VENTILATED AREA.
Ventilation: MECHANICAL (GENERAL): STANDARD PLANT AIR MOVEMENT SUFFICIENT.
Other Protective Equipment: EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET ANSI
DESIGN CRITERIA (FP N).
Work Hygienic Practices: WASH HANDS W/SOAP & WATER AFTER HANDLING MATERIAL,
ESPECIALLY BEFORE TOUCHING FACE, EATING OR SMOKING.
Supplemental Safety and Health: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Physical/Chemical Properties
=======================================================
Vapor Pres: <1
Vapor Density: >1
Solubility in Water: MODERATE
Appearance and Odor: PAPER W/SLIGHT CHARACTERISTIC ODOR.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Materials To Avoid: NONE ESTABLISHED.
Hazardous Decomposition Products: CARBON MONOXIDE, HYDROCARBONS & NITROUS
OXIDES.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: VW60H
Cage: EO631
Assigned IND: Y
Company Name: DAUBERT COATED PRODUCTS, INC
Street: 1200 JORIE BLVD.
Zipcode: 60521
Label Required IND: Y
Date Of Label Review: 07/28/1997
Status Code: C
Label Date: 07/28/1997
Origination Code: G
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Moderate
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: ACUTE:EYES:CAN CAUSE INTENSE PAIN WHEN IN DIRECT
CONTACT. SKIN:CAN CAUSE IRRITATION FROM DIRECT CONTACT. CHRONIC:NONE LISTED
BY MANUFACTURER.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ETHYLENE GLYCOL 09400, E178 1
CAGE:1B464
CAGE:1B464
============= Composition/Information on Ingredients =============
Ingred Name:ETHYLENE GLYCOL (SARA 313) (CERCLA)
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: >99%
OSHA PEL:N/K
ACGIH TLV:C 50 PPM, VAPOR
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:FIRST AID PROC:FROM EXPOS TO FRESH AIR IMMED. IF NOT BRTHG,
GIVE ARTF RESP. IF BRTHG IS DFCLT, GIVE OXYG. GET (ING 3)
RTECS #:9999999ZZ
Ingred Name:ING 2:MED AID IF COUGH/OTHER SYMPTOMS APPEAR. NOTES TO
PHYS:TREAT SYMPTOMATICALLY & SUPPORTIVELY. THE ADMIN OF (ING 4)
RTECS #:9999999ZZ
Ingred Name:ING 3:ETHANOL TO BLOCK THE PRODUCTION OF TOXIC METABOLITES
SHOULD BE EVALUATED ONLY BY QUALIFIED MEDICAL PERSONNEL.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(ORAL,RAT) 4700 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYE:MAY CAUSE MOD IRRIT.
SKIN:LOW HAZ FOR USUAL INDUST HNDLG. MAY BE ABSORBED THRU SKIN.
INGEST:MAY CAUSE NAUS & VOMIT. TOX FOLLOWS 3-STAGE PROGRESSION.
(1)INVOLVES CNS EFTS INCL PARAL OF EYE MU SCLES, CONVL, & COMA.
METABOLIC ACIDOSIS & CEREBRAL SWELL MAY ALSO OCCUR. (2)INVOLVES
CARDIOPULM SYS(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:W/SYMPS OF HYPERTENSION, RAPID HEART
BEAT, & POSS CARD FAILURE. (3)INVOLVES SEV KIDNEY ABNORM INCL POSS
RENAL FAILURE. INHAL:MAY CAUSE RESP TRACT IRRIT. IF HEATED,
DUST/FUME MAY CAUSE RESP TR ACT IRRIT. HEATED/MISTED SUBSTANCE MAY
CAUSE HDCH, IRREGULAR EYE MOVEMENTS, & POSS COMA. TARGET
ORGANS:KIDNEYS, (SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES:IMMED FLUSH W/PLENTY OF WATER FOR @ LST 15 MINS,
OCCASNLY LIFTING UPPER & LOWER LIDS. GET MED AID IMMED. DO NOT
ALLOW VICTIM TO RUB/KEEP EYES CLSD. SKIN:FLUSH W/PLENTY OF SOAP &
WATER FOR @ LST 1 5 MINS WHILE REMOVING CONTAMD CLTHG & SHOES. GET
MED AID IF IRRIT DEVELOPS/PERSISTS. INGEST:IF VICTIM IS CONSCIOUS &
ALERT, GIVE 2-4 CUPFULS OF MILK/WATER. GET MED AID IMMED.
INHAL:REMOVE (ING 2)
===================== Fire Fighting Measures =====================
Flash Point:232F,111C
Lower Limits:3.2%
Upper Limits:15.3%
Extinguishing Media:USE WATER, DRY CHEMICAL, CHEMICAL FOAM, OR
ALCOHOL-RESISTANT FOAM. WATER OR FOAM MAY CAUSE FROTHING.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB SPILL WITH INERT MATERIAL, (E.G., DRY
SAND OR EARTH), THEN PLACE INTO A CHEMICAL WASTE CONTAINER. REMOVE
ALL SOURCES OF IGNITION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM SOURCES OF IGNIT. STORE
IN A COOL, DRY, WELL-VENTILATED AREA AWAY FROM INCOMPTIBLE
SUBSTANCES.
Other Precautions:USE W/ADEQUATE VENT. GROUND & BOND CNTNRS WHEN
TRANSFERRING MATERIAL. AVOID CONT WITH SKIN & EYES. AVOID INGESTION
& INHALATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOLLOW THE OSHA RESPIRATOR REGULATIONS FOUND IN
29CFR1010.134. ALWAYS USE A NIOSH-APPROVED RESPIRATOR WHEN
NECESSARY.
Ventilation:USE ADEQUATE GENERAL/LOCAL EXHAUST VENTILATION TO KEEP
AIRBORNE CONCENTRATIONS BELOW THE PERMISSIBLE EXPOSURE LIMITS.
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER . WEAR
APPROP CLOTHING TO PREVENT SKIN EXPOSURE.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. REMOVE
CONTAMINATED CLOTHING & WASH BEFORE REUSE.
Supplemental Safety and Health
MATLS TO AVOID:HYDROXIDE, SULFURIC ACID, TITANIUM BUTOXIDE. CAUSES
IGNIT @ ROOM TEMP W/CHROMIUM TRIOXIDE, POTASSIUM PERMANGANATE, &
SODIUM PEROXIDE. CAUSES IGNIT @ 100C W/AMMONIUM DICHROMATE, SILVER
C HLORATE, SODIUM CHLORIDE & URANYL NITRATE. EFTS OF OVEREXP:HEART,
CNS, RESP SYS. CHRONIC:MAY CAUSE KIDNEY INJURY.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:387F,197C
Melt/Freeze Pt:M.P/F.P Text:9F,-13C
Vapor Pres:0.05 @ 20C
Vapor Density:2.1
Spec Gravity:1.11 (WATER =1)
Evaporation Rate & Reference:NOT AVAILABLE
Solubility in Water:SOLUBLE
Appearance and Odor:CLEAR, COLORLESS, VISCOUS, SWEET-TASTING LIQUID. NO
ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CHLOROSULFONIC ACID, DIMETHYL TEREPHTHALATE, OLEUM, PHOSPHORUS
PENTASULFIDE, SILVERED-COPPER WIRE, SODIUM (SUPDAT)
Stability Condition to Avoid:INCOMPATIBLE MATERIALS, IGNITION SOURCES,
CONTACT WITH WATER, EXCESS HEAT.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN A MANNER CONSISTENT WITH FEDERAL,
STATE, AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PAINT REMOVER 3403
CAGE:IO219
CAGE:IO219
CAGE:91522
============= Composition/Information on Ingredients =============
Ingred Name:METHYLENE CHLORIDE(SARA III)
CAS:75-09-2
RTECS #:PA8050000
Fraction by Wt: <75%
OSHA PEL:500 PPM/C,1000; Z2
ACGIH TLV:50 PPM, A2; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:PROPYLENE DICHLORIDE
CAS:563-54-2
RTECS #:UC8300000
Fraction by Wt: <10%.
ACGIH TLV:75 PPM
Ingred Name:METHYL ALCOHOL (METHANOL) (SARA III)
CAS:67-56-1
RTECS #:PC1400000
Fraction by Wt: 5%.
OSHA PEL:S,200PPM/250STEL
ACGIH TLV:S,200PPM/250STEL; 93
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:CHROMATE SALTS (TRACE AMTS)
ACGIH TLV:0.05 MG/CUM
Ingred Name:AMMONIA (SARA III)
CAS:7664-41-7
RTECS #:BO0875000
Fraction by Wt: 4%.
OSHA PEL:50 PPM
ACGIH TLV:25 PPM/35 STEL; 9293
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
Effects of Overexposure:INHAL: ANESTHETIC. LOSS OF COORD, DIZZ, SLIGHT
NAUSEA. SKIN & EYE: PRIMARY IRRIT.
======================= First Aid Measures =======================
First Aid:INGEST: IMMED CALL MD REMOVE TO FRESH AIR & HAVE VICTIM LIE
DOWN & KEEP WARM.COVER EYES TO EXCLUDE LIGHT. SKIN OR EYE CONTACT:
FLUSH IMMEDIATELY W/PLENTY OF WATER (15 MIN FOR EYES)
===================== Fire Fighting Measures =====================
Flash Point:NO FLASH TO BP
Lower Limits:3.40
Extinguishing Media:CO*2, DRY POWDER CLASS ABC EXTINGUISHERS
Fire Fighting Procedures:ISOLATE FRM HEAT & HOT SURFS
Unusual Fire/Explosion Hazard:CONTACT W/FLAMES OR HOT SURFACES MAY
GENERATE TOXIC FUMES, WHICH MAY ALSO BE CORROSIVE TO METAL SURF
================== Accidental Release Measures ==================
Spill Release Procedures:AVOID BREATHING OF VAPORS. VENTILATE AREA.
REMOVE W/INERT ABSORBENT.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE NEAR OPEN FLAMES OR AT
ELEVATED TEMPRATURES
Other Precautions:CONTACT W/SKIN MAY CAUSE IRRITATION. KEEP CONTAINER
CLOSED WHEN NOT IN USE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:CHEM FLTR CRTRDG RESP OR ENGINEERED AIR CONTROL
SYSTEMS
Ventilation:USE ONLY W/ADEQUATE VENTILATION
Other Protective Equipment:AVOID PROLONGED OR REPEATED SKIN CONTACT -
Supplemental Safety and Health
PRODUCT ALSO CONTAINS 3% METHOCEL 65 HG (METHYL CELLULOSE) AND 2% WAX.
VAPOR DENSITY IS HEAVIER THAN AIR.
================== Physical/Chemical Properties ==================
HCC:T4
Boiling Pt:B.P. Text:103 TO 205F
Evaporation Rate & Reference:<1 ETHER
Percent Volatiles by Volume:98.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:OPEN FLAMES AND ELECTRIC ARC
Hazardous Decomposition Products:HCL, PHOSGENE & OTHER TOXIC PRODUCTS
IN SM QUANTITIES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE W/LOCAL, STATE, FED
REGULATIONS
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:7133 LAWN GREEN T, 8049418
CAGE:DO804
CAGE:DO804
CAGE:38360
============= Composition/Information on Ingredients =============
Ingred Name:ETHANOL, 2-(2-BUTOXYETHOXY)-, ACETATE; (DIETHYLENE GLYCOL
MONOBUTYL ETHER ACETATE)
CAS:124-17-4
RTECS #:KJ9275000
Fraction by Wt: 10-25%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: MODERATE IRRITATION, REDNESS,
TEARING. SKIN: SLIGHT IRRITATION. INHAL: NASAL & RESP IRRITATION,
CENTRAL NERVOUS SYSTEM EFFECTS INCLUDING DIZZINESS, WEAKNESS,
FATIGUE, NAUSEA, HEADACHE AND POSSIB LE UNCONSCIOUSNESS & EVEN
DEATH. INGEST: GASTROINTESTINAL IRRITATION, NAUSEA, VOMITING &
DIARRHEA.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:NOTES TO PHYSICIAN: CHRONIC OVEREXPOSURE TO
DIETHYLENE GLYCOL MONOBUTYL ETHER ACETATE IN ANIMALS HAS BEEN
REPORTED TO CAUSE KIDNEY DAMAGE.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR AT LEAST 15 MINUTES. CALL MD IMMED.
SKIN: WASH W/SOAP & WATER FOR AT LEAST 15 MINUTES. GET MED ATTN.
INHAL: REMOVE TO FRESH AIR. ADMIN OXYGEN IF BREATHING IS DIFFICULT.
BEGIN R ESUSCITATION IF BREATHING HAS STOPPED. KEEP PERSON WARM &
QUIET. GET MED ATTN IMMED. INGEST: IF CONSCIOUS, GIVE TWO GLASSES
OF WATER & INDUCE VOMITING. GET MED ATTN IMMED.
===================== Fire Fighting Measures =====================
Flash Point:237F,114C
Extinguishing Media:DRY CHEMICAL, CO*2, ALCOHOL FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT.
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR & MAY TRAVEL
ALONG THE GROUND & MAY BE IGNITED AT DISTANT LOCATIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIM ALL SOURCES OF IGNIT. ABSORB SPILLED MATL
W/VERMICULITE OR FLOOR ABSORB. DISP OF CONTAMD MATLS PROPERLY. USE
TO OSHA STD: 29CFRPT 1910.120 HAZ WASTE OPS AND EMER RESPONSE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:FOR FLAMMABLE/COMBUSTIBLE PRODUCTS
FOLLOW STORAGE & HANDLING GUIDELINES PRESENTED IN NFPA 30 FLAMMABLE
& COMBUSTIBLE LIQUIDS CODE.
Other Precautions:CNTNRS OF THESE MATLS MAY BE HAZ WHEN EMPTIED, SINCE
EMPTIED CNTNRS RETAIN PROD RESIDUES WHICH CAN GENERATE VAPS W/IN
FLAMMABLE LIMITS. THE USE OF HAZ CHEM MAY REQ SUPPLEMENTAL VENT FOR
PROT OF PERS & FOR CONTROLLING FIRE/EXPLO (SUPP DATA)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPRVD RESP APPROP FOR EXPOS OF
CONCERN. SUFFICIENT TO MNTN OPERATOR EXPOS BELOW APPLIC OCCUP EXPOS
STDS. ENGINEERING/ADMIN CONTROLS OF NIOSH/MSHA RESPS CAN BE USED TO
REDUCE EXPOS. E NGINNERING CONTROLS ARE PREF BY OSHA.
Ventilation:SUFFICIENT TO MAINTAIN OPERATOR EXPOSURE BELOW APPLICABLE
OCCUPATIONAL EXPOSURE STANDARDS.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:LAUNDER CONTAMINATED CLOTHING BEFORE REUSE. GET
MEDICAL ATTENTION.
Supplemental Safety and Health
WASTE DISP METH: MATL HAZARDOUS. CONTACT FED, STATE & LOC AUTHORITIES
FOR DISP INFO. CONSULT 40CFR PART 261 IDENTIFICATION & LISTING OF
HAZARDOUS WASTE. OTHER PRECS: HAZARD. A QUALIFIED INDEPENDENT TE
STING COMPANY CAN DETERMINE IF THE EXISTING CONC ARE WITHIN THE
ESTABLISHED RECOMMENDED/PERMISSIBLE EXPOSURE LEVELS.
================== Physical/Chemical Properties ==================
Vapor Pres:VERY LOW
Evaporation Rate & Reference:VERY SLOW
Solubility in Water:NEGLIGIBLE
Appearance and Odor:LIQUID OR SEMI-SOLID INK AS COLOR ABOVE.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ALKALIES, STRONG MINERAL ACIDS.
Stability Condition to Avoid:HEAT & FLAME.
Hazardous Decomposition Products:CO, CO*2.
==================== Disposal Considerations ====================
Waste Disposal Methods:UNDER RESOURCE CONSERVATION & RECOVERY
ACT(RCRA), IT IS RESPONSIBLITY OF GENERATOR OF WASTE TO DETERMINE
WHETHER WASTE GENERATED MEETS FED, STATE, LOC HAZ WASTE CRITERIA.
USES, TRANSFORMATIONS, MIXTUR ES, PROCESSES,ETC., MAY RENDER RSLTG
(SUPP DATA)
| 1 | gloves_mandatory |
=======================================================
Product ID: COPPER RED IRON OXIDE, R-9998
Cage: GO125
=======================================================
Contractor Summary
=======================================================
Cage: GO125
=======================================================
Ingredients
=======================================================
Cas: 1332-37-2
RTECS #: NO7380000
% Wt: >92
OSHA PEL: N/K (FP N)
ACGIH TLV: 5 MG/M3 (MFR)
------------------------------
Cas: 1317-61-9
% Wt: <8
OSHA PEL: 10 MG/M3
ACGIH TLV: 5 MG/M3
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE: MAY CAUSE MECH SKIN & EYE IRRIT. RPTD &
PRLNG EXPOS TO IRON OXIDE DUST MAY CAUSE BENIGN PNEUMOCONIOSIS CALLED
SIDEROSIS. CHRONIC: PRLNG INHAL OF IRON OXIDE DUST IS KNOWN TO PRDCE A CNDTN
KNOWN AS SIDEROSIS. ON X-RAYS IT APPEARS TO BE A BENIGN PNEUMOCONIOSIS &
IS NOT ASSOC W/PULM FIBROSIS OR (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: HLTH HAZ: DISABILITY UNLESS THERE IS
CONCURRENT EXPOS TO OTHER FIBROSIS-PRODUCING MATLS SUCH AS SILICA. TLV IS SET
TO PROTECT AGAINST SIDEROSIS.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: EYES: FLUSH WITH GENEROUS AMOUNTS OF WATER FOR AT LEAST 15 MINUTES.
CALL MD IF IRRITATION PERSISTS. SKIN: WASH WITH MILD SOAP AND WATER.
INHALATION: REMOVE TO FRESH AIR. CALL MD. INGESTION: IF CONSCIO US, GIVE
LARGE QUANTITIES OF WATER TO INDUCE VOMITING. GET MEDICAL ATTENTION.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: VACCUM OR USE WET CLEAN-UP TECHNIQUES AND PLACE WASTE
MATERIAL IN CLOSED CONTAINER.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSAL MUST BE MADE IN ACCORDANCE WITH FEDERAL, STATE
AND LOCAL REGULATIONS. PURSUANT TO 40 CFR PART 261 OF THE RCRA. REGULATIONS
CURRENTLY IN EFFECT, DISCARDED IRON OXIDE WOULD NOT BE CLASSIFIED AS
HAZARDOUS WASTE.
Handling And Storage Precautions: FOR TRANSPORTATION EMERGENCIES, CALL
CHEMTREC, 24 HOUR INFORMATION SERVICE, (800) 424-9300.
Other Precautions: AVOID BREATHING DUST. KEEP AWAY FROM FOOD PRODUCTS. KEEP
CONTAINER CLOSED WHEN NOT IN USE. USE WITH ADEQUATE, LOCALIZED VENTILATION.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: NOT FLAMMABLE
Extinguishing Media: NOT FLAMMABLE. USE APPROPRIATE EXTINGUISHING MEDIA FOR THE
COMBUSTIBLE MATERIAL INVOLVED IN THE FIRE.
Fire Fighting Procedures: WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: NONE.
=======================================================
Control Measures
=======================================================
Respiratory Protection: USE OF NIOSH APPROVED DUST RESPIRATORS IS RECOMMENDED
WHEN EXPOSURE LIMITS MAY BE EXCEEDED.
Ventilation: LOCAL EXHAUST VENTILATION TO COLLECTOR OR CONTAINMENT RECOMMENDED
TO CONTROL DUST TO BELOW EXPOSURE LIMITS.
Other Protective Equipment: EMERGENCY EYEWASH AND DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA (FP N).
Work Hygienic Practices: I/A/W GOOD INDUS HYGIENE PRACT, AVOID CONT W/SKIN,
EYES/CLTHG. WASH THORO AFTER HNDLG & BEFORE EATING, (SUP DAT)
Supplemental Safety and Health: HYGIENE PRACT: DRINKING/USING TOBACCO PRODUCTS.
=======================================================
Physical/Chemical Properties
=======================================================
Spec Gravity: 4.03 (H*2O=1)
Solubility in Water: INSOLUBLE
Appearance and Odor: RED POWDER, NO ODOR
Percent Volatiles by Volume: 0
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE.
Materials To Avoid: IT IS INCOMPATIBLE WITH HYDRAZINE, CALCIUM HYPOCHLORITE,
PERFORMIC ACID, AND BROMINE PENTAFLUORIDE.
Hazardous Decomposition Products: NONE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: COPPER RED IRON OXIDE, R-9998
Cage: GO125
Assigned IND: Y
Company Name: HARCROS PIGMENTS INC
Street: 1525 WOOD AVE
Zipcode: 18042
Label Required IND: Y
Date Of Label Review: 10/21/1997
Status Code: C
Label Date: 10/21/1997
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE: MAY CAUSE MECHANICAL SKIN AND EYE IRRITATION.
REPEATED AND PROLONGED EXPOSURE TO IRON OXIDE DUST MAY CAUSE BENIGN
PNEUMOCONIOSIS CALLED SIDEROSIS. CHRONIC: PROLONGED INHALATION OF IRON OXIDE
DU ST IS KNOWN TO PRODUCE A CONDITION KNOWN AS SIDEROSIS. ON X-RAYS IT
APPEARS TO BE A BENIGN PNEUMOCONIOSIS AND IS NOT ASSOCIATED WITH PULMONARY
FIBROSIS OR DISABILITY UNLESS THERE IS CONCURRENT EXPOSUR E TO OTHER
FIBROSIS-PRODUCING MATERIALS SUCH AS SILICA. THE TLV IS SET TO PROTECT
AGAINST SIDEROSIS.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MOBIL DTE 15M
Preparer's Name:NOT PROVIDED
CAGE:3U728
Contract Num:SP0450-01-M-LH53
CAGE:1K1V5
Contract Num:SP0450-01-M-LE23
CAGE:1MDA6
Contract Num:SP0450-00-M-C232
CAGE:0WA27
CAGE:3U728
============= Composition/Information on Ingredients =============
Ingred Name:PRODUCT ASSESSED IN ACCORDANCE WITH OSHA 29 CFR 1910.1200
AND DETERMINED TO NOT TO BE HAZARDOUS.
Other REC Limits:NOT PROVIDED
OSHA PEL:NONE
ACGIH TLV:NONE
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT) > 2,000 MG/KG
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EFFECTS OF OVEREXPOSURE: NO
SIGNIFICANT EFFECTS EXPECTED. ACUTE TOXICOLOGY- ORAL TOXICITY
(RATS): PRACTICALLY NON-TOXIC. DERMAL TOXICITY (RABBITS):
PRACTICALLY NON-TOXIC. INHALATION TOXICITY (RATS): N OT APPLICABLE.
HARMFUL CONCENTRATIONS OF MISTS AND/OR VAPORS ARE UNLIKELY TO BE
ENCOUNTERED THROUGH ANY CUSTOMERY / REASONABLY FORESEEABLE
HANDLING, USE/ MISUSE OF THIS PRODUCT. EYE IRRITATION (RABBIT S):
PRACTICALLY NON-IRRITATING. SKIN IRRITATION (RABBITS): PRACTICALLY
NON-IRRITATING. CHRONIC TOXICITY: THE BASE OILS IN THIS PRODUCT ARE
SEVERELY SOLVENT REFINED AND/OR SEVERELY HYDROTREATED AND SHO WED
NO EVIDENCE OF CARCINOGENIC EFFECTS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:NOT PROVIDED
Medical Cond Aggravated by Exposure:NOT PROVIDED
======================= First Aid Measures =======================
First Aid:EYE CONTACT: FLUSH THOROUGHLY WITH WATER. IF IRRITATION
OCCURS, CALL A PHYSICIAN. SKIN CONTACT: WASH CONTACT AREAS WITH
SOAP AND WATER. HIGH PRESSURE ACCIDENTAL INJECTION THROUGH THE SKIN
REQUIRES IMM EDIATE MEDICAL ATTENTION FOR POSSIBLE INCISION,
IRRIGATION AND/OR DEBRIDEMENT. INHALATION: NOT EXPECTED TO BE A
PROBLEM. INGESTION: NOT EXPECTED TO BE A PROBLEM. HOWEVER, IF MORE
THAN 1/2 LITER (PINT) INGESTED, SEEK MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:>166.1C, 331.F
Autoignition Temp:Autoignition Temp Text:N/E
Lower Limits:NA
Upper Limits:NA
Extinguishing Media:CARBON DIOXIDE, FOAM, DRY CHEMICAL, WATER FOG. USE
WATER TO KEEP FIRE EXPOSED CONTAINERS COOL.
Fire Fighting Procedures:WATER/FOAM MAY CAUSE FROTHING. WATER SPRAY MAY
BE USED TO FLUSH SPILLS AWAY FROM EXPOSURE. PREVENT RUNOFF FROM
FIRE CONTROL OR DILUTION FROM ENTERING STREAMS, SEWERS OR DRINKING
WATER SUPPLY. FOR FIRE S IN ENCLOSED AREAS, FIRE FIGHTERS MUST USE
SELF CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:NOTE: PRESSURIZED MISTS MAY FORM A
FLAMMABLE MIXTURE.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. REPORT SPILLS THAT
COULD REACH WATERWAYS INCLUDING INTERMITTENT DRY CREEKS AS REQUIRED
TO COAST GUARD AT 800-424-8802. IN CASE OF ROAD SPIIL, CALL
CHEMTREC (800-424-9300). A DSORB ON FIRE RETARDANT TREATED SAWDUST,
DIATOMACEOUS EARTH. SHOVEL UP AND DISPOSE OF AT AN APPROPRIATE
WASTE DISPOSAL FACILITY. PREVENT SPILLS FROM ENTERING STORM
SEWERS, DRAIN, CONTACT WITH SOIL.
Neutralizing Agent:NOT PROVIDED
======================Handling and Storage ======================
Handling and Storage Precautions:HIGH PRESSURE INJECTION UNDER THE SKIN
MAY OCCUR DUE TO THE RUPTURE OF PRESSURIZED LINES. ALWAYS SEEK
MEDICAL ATTENTION. DO NOT STORE IN OPEN OR UNLABELLED CONTAINERS.
STORE AWAY FROM STRONG OXIDZING AGENTS OR COMBUSTIBLE MATERIAL.
Other Precautions:NOT PROVIDED
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NO SPECIAL REQUIREMENTS UNDER ORDINARY
CONDITIONS OF USE & WITH ADEQUATE VENTILATION.
Ventilation:NO SPECIAL REQUIREMENTS UNDER ORDINARY CONDITIONS OF USE &
WITH ADEQUATE VENTILATION.
EMPLOYED.
Other Protective Equipment:NOT PROVIDED
Work Hygienic Practices:FOLLOW GOOD PERSONAL HYGIENE PRACTICE.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:V6
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:>316.C, 600.8F
Melt/Freeze Pt:M.P/F.P Text:NE
Decomp Temp:Decomp Text:NOT PROVIDED
Vapor Pres:NE
Vapor Density:>2
Spec Gravity:0.875
pH:NA
Viscosity:>42.8 CST @ 40C/104F
Evaporation Rate & Reference:NE
Solubility in Water:NEGLIGIBLE
Appearance and Odor:AMBER LIQUID, MILD ODOR.
Corrosion Rate:NOT PROVIDED
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Stability Condition to Avoid:EXTREME HEAT
Hazardous Decomposition Products:CARBON MONOXIDE. METAL OXIDES.
ELEMENTAL OXIDES.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
=================== Toxicological Information===================
Toxicological Information:ORAL TOXICITY (RATS): PRACTICALLY NON-TOXIC
(LD50: GREATER THAN 2000 MG/KG)- BASED ON TESTING OF SIMILAR
PRODUCTS AND/OR THE COMPONENTS. DERMAL TOXICITY (RABBITS):
PRACTICALLY NON-TOXIC (LD50: GREATE R THAN 2000 MG/KG)- BASED ON
TESTING OF SIMILAR PRODUCTS AND/OR THE COMPONENTS.INHALATION
TOXICITY (RATS): NOT APPLICABLE -- HARMFUL CONCENTRATIONS OF MISTS
ADN/OR VAPORS ARE UNLIKELY TO BE ENCOUNT ERED THROUGH ANY CUSTOMARY
OR REASONABLEY FORESEEABLE HANDLING, USE, OR MISUSE OF THIS
PRODUCT. EYE IRRITATION (RABBITS): PRACTICALLY NON-IRRITATING.
(DRAIZE SCORE: GREATER THAN 6 BUT 15 OR LESS). -- BASED ON TESTING
OF SIMILAR PRODUCTS.
===================== Ecological Information =====================
Ecological:ENVIRONMENTAL FATE AND EFFECTS: THIS PRODUCT IS EXPECTED TO
BE INHERENTLY BIODEGRADABLE. THERE IS NO EVIDENCE TO SUGGEST
BIOACCUMULATION WILL OCCUR. IT IS NOT EXPECTED TO BE TOXIC TO
AQUATIC ORGANISMS . ACCIDENTAL SPILLAGE MAY LEAD TO PENETRATION IN
THE SOIL AND GROUNDWATER. HOWEVER, THERE IS NO EVIDENCE THAT THIS
WOULD CAUSE ADVERSE ECOLOGICAL EFFECTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:PRODUCT IS SUITABLE FOR BURNING IN AN ENCLOSED,
CONTROLLED BURNER FOR FUEL VALUE OR DISPOSAL BY SUPERVISED
INCINERATION. SUCH BURNING MAY BE LIMITED PURSUANT TO THE RESOURCE
CONSERVATION AND RECOVERY ACT. IN ADDITION, PRODUCT IS SUITABLE
FOR PROCESSING BY AN APPROVED RECYCLING FACILITY OR CAN BE DIS
POSED OF ACCORDING TO REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:USA DOT: NOT REGULATED BY USA DOT. IMO: NOT
REGULATED BY IMO. IATA: NOT REGULATED BY IATA.
===================== Regulatory Information =====================
SARA Title III Information:U.S. SUPERFUND AMENDMENTS AND
REAUTHORIZATION ACT (SARA) TITLE III: THIS PRODUCT CONTAINS NO
"EXTREMELY HAZARDOUS SUBSTANCES". SARA (311/312) REPORTABLE HAZARD
CATEGORIES: NONE. THIS PRODUCT CONTAINS NO CHEMICALS REPORTABLE
UNDER SARA (313) TOXIC RELEASE PROGRAM.
Federal Regulatory Information:ALL COMPONENTS COMPLY WITH TSCA. RCRA
INFORMATION: THE UNUSED PRODUCT, IN MFR OPINION, IS NOT
SPECIFICALLY LISTED BY THE EPA AS A HAZARDOUS WASTE (40 CFR, PART
261D), NOR IS IT FORMULATED TO CONTAIN M ATERIALS WHICH ARE LISTED
HAZARDOUS WASTES. IT DOES NOT EXHIBIT THE HAZARDOUS CHARACTERISTICS
OF IGNITABILITY, CORROSIVITY, OR REACTIVITY AND IS NOT FORMULATED
WITH CONTAMINANTS AS DETERMINED BY THE T OXICITY CHARACTERISTIC
LEACHING PROCEDURE (TCLP). HOWEVER, USED PRODUCT MAY BE REGULATED.
State Regulatory Information:THE FOLLOWING PRODUCT INGREDIENTS ARE
CITED ON THE LISTS BELOW: ZINC (ELEMENTAL ANALYSIS) (0.10%)
7440-66-6 (MI 293); PHOSPHORODITHOIC ACID, O,O-DIC1-14-ALKYL
ESTERS, ZINC SALTS (2:1) (ZDDP) (0.67%) 6 8649-42-3 (MI 293).
======================= Other Information =======================
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:SODIUM HEXAMETAPHOSPHATE
Resp. Party Other MSDS Num.:REFERENCE NUMBER: AST 10053
CAGE:1RKV8
CAGE:1RKV8
Contract Num:SP0450-01-M-ZB11
CAGE:71229
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM HEXAMETAPHOSPHATE
CAS:68915-31-1
RTECS #:TR4950250
= Wt:100.
OSHA PEL:15 MG/M3(T DUST)8HR
ACGIH TLV:19 MG/M3(INHAL)8HR
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL, RAT, LD50:8,600 MG/KG
Health Hazards Acute and Chronic:NO SIGNIFICIANT HAZARDS ASSOCIATED
WITH THIS MATERIAL. EYE CONTACT: NO MORE THAN SLIGHTLY IRRITATING
BASED ON TOXICITY STUDIES. THE DRY MATERIAL MAY CAUSE FOREIGN BODY
IRRITATION ON SOME INDIVIDUALS. SKIN CONTACT: NO MORE THAN
SLIGHTLY TOXIC OR SLIGHTLY IRRITATING BASED ON TOXICITY STUDIES.
PROLONGED CONTACT WITH THE DRY MATERIAL MAY CAUSE DRYING OR
CHAPPING OF THE SKIN. INHALATION: INHALATION OF THE DUST MAY CAUSE
COUGHING AND SNEEZING. INGESTION: NOT TOXIC IF SWALLOWED BASED ON
TOXICITY STUDIES. NO SIGNIFICANT ADVERSE HEALTH EFFECTS ARE
EXPECTED IF ONLY SMALL AMOUNTS (LESS THAN A MOUTHFUL) A RE
SWALLOWED.
Effects of Overexposure:EYE CONTACT: IRRITATATION. SKIN CONTACT:
IRRITATION, DRYING OR CHAPPING OF SKIN. INHALATION: COUGHING AND
SNEEZING. INGESTION: NO ADVERSE HEALTH EFFECTS EXPECTED IF ONLY
SMALL AMOUNTS (LESS THAN A MOU THFUL) ARE SWALLOWED.
======================= First Aid Measures =======================
First Aid:IF IN EYES OR ON SKIN: IMMEDIATE FIRST AID IS NOT LIKELY TO
BE REQUIRED. HOWEVER, THIS MATERIAL CAN BE REMOVED WITH WATER.
REMOVE MATERIAL FROM EYES, SKIN AND CLOTHING. WASH HEAVILY
CONTAMINATED CLOTH ING BEFORE REUSE. IF INHALED: IMMEDIATE FIRST
AID IS NOT LIKELY TO BE REQUIRED. HOWEVER, IF SYMPTOMS OCCUR,
REMOVE TO FRESH AIR. IF SWALLOWED: IMMEDIATE FIRST AID IS NOT
LIKELY TO BE REQUIRED. A PHYSI CIAN OR POISON CONTROL CENTER CAN BE
CONTACTED FOR ADVICE.
===================== Fire Fighting Measures =====================
Flash Point:NON COMBUSTIBLE
Lower Limits:NA
Upper Limits:NA
Extinguishing Media:NA
Unusual Fire/Explosion Hazard:NONE KNOWN
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP, SCOOP OR VACUUM AND REMOVE FOR
DISPOSAL. FLUSH RESIDUAL SPILL AREA WITH WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLE IN ACCORDANCE WITH GOOD
INDUSTRIAL HYGIENE AND SAFETY PRACTICES. THESE PRACTICES INCLUDE
AVOIDING UNNECESSARY EXPOSURE AND REMOVAL OF MATERIAL FROM EYES,
SKIN, AND CLOTHING. STORE IN A COOL, DR Y PLACE TO MAINTAIN PRODUCT
PERFORMANCE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AVOID BREATHING DUST. USE NIOSH/MSHA APPROVED
RESPIRATORY PROTECTION EQUIPMENT WHEN AIRBORNE EXPOSURE LIMITS ARE
EXCEEDED. CONSULT THE RESPIRATOR MANUFACTURER TO DETERMINE
APPROPRIATE TYPE EQUIPMENT F OR A GIVEN APPLICATION. OBSERVE
RESPIRATOR USE LIMITATIONS SPECIFIED BY NIOSH/MSHA OR THE MFR.
RESPIRATORY PROTECTION PROGRAMS MUST COMPLY WITH 29 CFR 1910.134.
Ventilation:PROVIDE NATURAL OR MECHANICAL VENTILATION TO CONTROL
EXPOSURE LEVELS BELOW AIRBORNE EXPOSURE LIIMITS. LOCAL MECHANICAL
EXHAUST VENTILATION IS PREFERRED.
SKIN CONTAMINATION.
PRACTICE TO AVOID EYE CONTACT.
Other Protective Equipment:OSHA AND ACGIH HAVE NOT ESTABLISHED
EXPOSURE LIMITS FOR THIS MATERIAL. HOWEVER, OSHA AND ACGIH HAV
ESTABLISHED LIMITS FOR PARTICULATES NOT OTHERWISE CLASSIFIED
(PNOC). (SEE "TOXICOLOGICAL").
Work Hygienic Practices:USE GOOD INDUSTRIAL PRACTICE TO AVOID EYE
CONTACT. MINIMIZE SKIN CONTAMINATION BY FOLLOWING GOOD INDUSTRIAL
PRACTICE. WASH HANDS AND CONTAMINATED SKIN THOROUGHLY AFTER
HANDLING. AVOID BREATHING DUST.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:=628.C, ######F
Spec Gravity:POWDER:78-84 LB/FT3
pH:7.0 (AS 1% SOL)
Solubility in Water:INFINITELY SOLUBLE
Appearance and Odor:WHITE POWDER, GRANULES, OR GLASS PLATES, NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:SOLUTIONS OF THIS PRODUCT WILL HYDROLYZE
TO FORM ORTHO PHOSPHATE AND OTHER SHORTER CHAIN PHOSPHATES.
DISSOLUTION IS IMPACTED BY TERMPERATURE AND PH OF THE SYSTEM.
Hazardous Decomposition Products:NONE KNOWN.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
=================== Toxicological Information===================
Toxicological Information:AIRBORNE EXPOSURE LIMITS: OSHA PEL: 15 MG/M3
(TOTAL DUST) 8-HR TWA; 5 MG/M3 (RESPIRABLE) 8-HR TWA. ACGIH TLV: 10
MG/M3 (INHALABLE) 8-HR TWA; 3 MG/M3 (RESPIRABLE) 8-HR TWA.
COMPONENTS REFERRED TO HEREI N MAY BE REGULATED BY SPECIFIC
CANADIAN PROVINCIAL LEGISLATION. PLEASE REFER TO EXPOSURE LIMITS
LEGISLATED FOR THE PROVINCE IN WHICH THE SUBSTANCE WILL BE USED.
ORAL, RAT, LD50: 8,600 MG/KG; PRACTICA LLY NONTOXIC. DERMAL,
RABBIT, LD50: >7,940 MG/KG; PRACTICALLY NONTOXIC. EYE IRRITATION,
RABBIT: 1.3/110.0: SLIGHTLY IRRITATING. SKIN IRRITATION, RABBIT
(24-HR EXP): 0.0/8.0; NONIRRITATING. RATS FED TH IS MATERIAL
(CONTD. SEE "ECOLOGICAL")
===================== Ecological Information =====================
Ecological:ASTARIS HAS NOT CONDUCTED ENVIRONMENTAL TOXICITY OR
BIODEGRADATION STUDIES WITH THIS PRODUCT. ASTARIS HAS NOT
CONDUCTEDR BIODEGRADATION STUDIES WITH THIS PRODUCT SINCE WHEN
DISSOLVED/HYDROLYZED IN WAT ER IT YIELDS COMPLETELY MINERALIZED
MATERIALS. (CONTD. FROM "TOXICOLOGICAL")INTHEIR DIET FOR ONE
MONTH SHOWED DECREASED GROWTH, INCREASED KIDNEY, LUNG, AND SPLEEN
WEIGHT, AND KIDNEY DAMAGE. RATS FED THIS MATERIAL FOR TWO YEARS
ALSO SHOWED DECREASED WEIGHT GAIN, INCREASED KIDNEY WEIGHT, AND
KIDNEY CHANGES. NO INCREASE IN TUMORS WAS REPORTED. NO ADVERSE
EFFECTS IN REPRODUCTIVE (CONTD. SEE "TRANSPO RT")
==================== Disposal Considerations ====================
Waste Disposal Methods:THIS MATERIAL WHEN DISCARDED IS NOT A HAZARDOUS
WASTE AS THAT TERM IS DEFINED BY THE RESOURCE CONSERVATION AND
RECOVERY ACT (RCRA), 40 CFR 261. DRY MATERIAL MAY BE LANDFILLED OR
RECYCLED IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS.
CONSULT YOUR ATTORNEY OR APPROPRIATE REGULATORY OFFICIAL S FOR
INFORMATION ON SUCH DISPOSAL.
=================== MSDS Transport Information ===================
Transport Information:THE DATA PROVIDED IN THIS SECTION IS FOR
INFORMATION ONLY. PLEASE APPLY THE APPROPRIATE REGULATIONS TO
PROPERLY CLASSIFY YOUR SHIPMENT FOR TRANSPORTATION. U.S. DOT: NOT
REGULATED FOR TRANSPORTATION. C ANADIAN TDG: NOT RGULATED FOR
TRANSPORTATION. (CONTD. FROM "ECOLOGICAL") CAPACITY WERE REPORTED
IN A MULTIGENERATION STUDY USING RATS FED THIS MATERIAL.
===================== Regulatory Information =====================
SARA Title III Information:SARA HAZARD NOTIFICATION:HAZARD CATEGORIES
UNDER TITLE I I I RULES (40 CFR 370): NOT APPLICABLE.SECTION 302
EXTREMELY HAZARDOUS SUBSTANCES: NOT APPLICABLE. SECTION 313 TOXIC
CHEMICALS: NOT APPLICABLE.CERCLA REPORTABLE QUANTITY: NOT
APPLICABLE.
Federal Regulatory Information:TSCA INVENTORY: LISTED. DSL INVENTORY:
LISTED.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:POWDERED METAL ALLOY, G40B
Preparer's Name:A.J. GREGUS
CAGE:GO164
CAGE:0R811
CAGE:GO164
============= Composition/Information on Ingredients =============
Ingred Name:ALUMINUM
CAS:7429-90-5
RTECS #:BD0330000
Fraction by Wt: 0-3%
Other REC Limits:NONE RECOMMENDED
ACGIH TLV:10 MG/M3
Ingred Name:BORON
CAS:7440-42-8
RTECS #:ED7350000
Fraction by Wt: 0-2%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 MG B203/M3
ACGIH TLV:10 MG B2O3/M3
Ingred Name:COBALT
CAS:7440-48-4
RTECS #:GF8750000
Fraction by Wt: 0-50%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.1 MG/M3
ACGIH TLV:0.1 MG/M3
Ingred Name:CHROMIUM
CAS:7440-47-3
RTECS #:GB4200000
Fraction by Wt: 0-25%
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:COPPER
CAS:7440-50-8
RTECS #:GL5325000
Fraction by Wt: 0-1%
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:IRON
CAS:7439-89-6
RTECS #:NO4565500
Fraction by Wt: 0-90%
Other REC Limits:NONE RECOMMENDED
Ingred Name:MANGANESE
CAS:7439-96-5
RTECS #:OO9275000
Fraction by Wt: 0-8%
Other REC Limits:NONE RECOMMENDED
Ingred Name:MOLYBDENUM
CAS:7439-98-7
RTECS #:QA4680000
Fraction by Wt: 0-10%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 PPM.
ACGIH TLV:10 PPM.
Ingred Name:NICKEL
CAS:7440-02-0
RTECS #:QR5950000
Fraction by Wt: 0-80%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3
Ingred Name:VANADIUM PENTOXIDE
CAS:1314-62-1
RTECS #:YW2450000
Fraction by Wt: 0-12%
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:TANTALUM
CAS:12070-06-3
Fraction by Wt: 0.20%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG TA/M3
ACGIH TLV:5 MG TA/M3
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 0-5%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:NO TOXIC EFFECTS WOLD BE EXPECTED FROM
ITS INERT SOLID FROM. PROLONGED EXPOSURE TO FUMES OR DUSTS
GENERATED DURING HEATING, CUTTING, BRAZING OR WELDING MAY CAUSE
ADVERSE HEALTH EFFECTS DUE TO SOME OF THE CONSTITUENTS MENTIONED
IN THE FORMULA OR TYPICAL ANALYSIS. SOME CONSTITUENTS POSE MORE
POTENTIAL HAZARDS THAN OTHERS
Explanation of Carcinogenicity:CHROMIUM AND NICKEL AND THEIR COMPOUNDS
ARE LISTED AS CARCINOGENS BY NTP & IARC. SEE INDIVIDUAL REPORTS FOR
DETAILS.
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION: INCASE OF OVEREXPOSURE, IMMEDIATELY MOVE PERSON
FROM CONTAMINATED AIR TO FRESH AIR AT ONCE. GIVE ARTIFICAL
RESPIRATION IF BREATHING HAS STOPPED OR OXYGEN IF NECESSARY. GET
MEDICAL ATTENTIO N IF NECESSARY.
===================== Fire Fighting Measures =====================
Extinguishing Media:NO FIRE OR EXPLOSION HAZARD.
================== Accidental Release Measures ==================
Spill Release Procedures:"NOT APPLICABLE"
======================Handling and Storage ======================
Handling and Storage Precautions:NO SPECIAL HANDLING IS REQUIRED IN ITS
INERT SOLID FORM. DURING WELDING, AIRBORN CONTAMINENTS & NOXIOUS
GASES MAY ORIGIONATE FROM THE WELDING ROD.
Other Precautions:"WE CANNOT COMPREHEND ALL OF THE VARIOUS SITUATIONS
THAT MAY ARISE IN THE USE OF OUR PRODUCTS, THEREFORE OUR CUSTOMERS
ARE RESPONSIVLE FOR ANY HAZARDS AND PRECAUTIONS NOT LISTED ON THIS
MATERIAL SAFET Y DATA SHEET."
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE DUST MASK WHEN HANDLING POWDER FORM OF
ALLOY.
Ventilation:USE OF EXHAUST SYSTEMS ARE SUGGESTED FOR ABRASIVE CUTTING,
GRINDING, WELDING, AND BURNING.
Other Protective Equipment:PRECAUTION SHOULD BE TAKEN TO PROTECT
AGAINST BURNS.
Work Hygienic Practices:USE GOOD INDUSTRIAL HYGIENE PRACTICE. AVOID
UNNECESSARY CONTACT. WASH THOROUGHLY BEFORE EATING OR DRINKING
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:5000F,2760C
Spec Gravity:0.3
Appearance and Odor:ODORLESS SOLID WITH METALLIC LUSTRE. AVAILABLE IN
SHEET, STRIP, BAR, ROD, BILLE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:METAL FUMES AND CERTAIN NOXIOUS GASES
SUCH AS CARBON MONOXIDE, MAY BE PRODUCED DURING WELDING OPERATIONS.
==================== Disposal Considerations ====================
Waste Disposal Methods:"NOT APPLICABLE" (IT IS RECOMMENDED THAT ALL
SCRAP GENERATED BE RECLAIMED AND SUBSEQUENTLY RECYCLED.)
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:2011, ALUMINUM WELDING WIRE
CAGE:CALL0
CAGE:CALL0
============= Composition/Information on Ingredients =============
Ingred Name:ING 11:OVEREXP TO LEAD HAS BEEN ASSOCD W/MALE/FEMALE REPROD
EFTS SUCH AS REDUCED FERTILITY IN BOTH MEN & WOMEN &(ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12:DAM TO FETUS OF EXPOSED PREGNANT WOMEN. SYMPS OF
CHRONIC LEAD OVEREXP INCLUDE TIREDNESS, IRRITABILITY, (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13:APPETITE LOSS, METALLIC TASTE, & LOSS OF SLEEP.
SINCE LEAD IS A CUMULATIVE TOX METAL BY INHAL/INGEST, (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14:APPROP INDUST HYGIENE PRECS (I.E., GOOD PERS
HYGIENE) TO GUARD AGAINST THESE 2 ROUTES OF EXPOS NEED TO BE(ING
14)
RTECS #:9999999ZZ
Ingred Name:ING 15:TAKEN.SAMPLING TO ESTABLISH LEAD LEVEL EXPOS IS
ADVISED WHERE EXPOS TO AIRBORNE PARTICULATE/FUMES IS (ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16:POSS.CONSULT OSHA LEAD STANDARD 29 CFR 1910.1025 FOR
SPECIFIC HLTH/INDUST HYGIENE PRECS & REQMTS TO (ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17: FOLLOW WHEN HANDLING LEAD COMPOUNDS. NOTE: LEAD
7439-92-1 APPEARS ON NAVY LISTING OF OCCUP REPROD HAZ. (ING 19)
RTECS #:9999999ZZ
Ingred Name:ING 18:SEEK CONSULTATION FROM APPROP HLTH PROFESSIONALS
CONCERNING LATEST HAZ LIST INFO & SAFE HNDLNG & EXPOS (ING 20)
RTECS #:9999999ZZ
Ingred Name:ING 19: RECOMMENDATIONS .
RTECS #:9999999ZZ
Ingred Name:ING 10:EXTENDED TIME CAN RSLT IN SUCH TOX EFTS AS
NEUROPATHY, GI DISTURBANCES, ANEMIA, & CHROMOSOMAL CHANGES. (ING
12)
RTECS #:9999999ZZ
Ingred Name:ALUMINUM (SARA III)
CAS:7429-90-5
RTECS #:BD0330000
Fraction by Wt: BALANCE
OSHA PEL:15 MG/M3 DUST;5 FUME
ACGIH TLV:10 MG/M3 DUST;5 FUME
Ingred Name:BERYLLIUM (SARA III)
CAS:7440-41-7
RTECS #:DS1750000
Fraction by Wt: <0.05%
OSHA PEL:2 UG/M3
ACGIH TLV:0.002PPM; A2; 9293
Ingred Name:COPPER (SARA III)
CAS:7440-50-8
RTECS #:GL5325000
Fraction by Wt: 5-6%
OSHA PEL:0.1MG/M3 FUME;1 DUST
ACGIH TLV:0.2MG/M3 FUME;1 DUST
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:IRON (PEL/TLV AS IRON OXIDE)
CAS:7439-89-6
RTECS #:NO4565500
Fraction by Wt: <0.7%
OSHA PEL:10 (FE) MG/M3
ACGIH TLV:5 (FE) MG/M3
Ingred Name:SILICON. LD50: (ORAL, RAT) 3160 MG/KG.
CAS:7440-21-3
RTECS #:VW0400000
Fraction by Wt: <0.4%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:ZINC (SARA III) (PEL/TLV AS ZINC OXIDE)
CAS:7440-66-6
RTECS #:ZG8600000
Fraction by Wt: <0.3%
OSHA PEL:10MG/M3 TDUST;5 FUME
ACGIH TLV:10MG/M3 TDUST;5 FUME
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:OTHER INGREDIENTS
Fraction by Wt: <0.15%
Ingred Name:LEAD (SARA III)
CAS:7439-92-1
RTECS #:OF7525000
Fraction by Wt: 0.2-0.6%
OSHA PEL:0.05 MG/M3
ACGIH TLV:0.15 MG/M3 DUST/FUME
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:BISMUTH (PEL/TLV AS BISMUTH TELLURIDE, SELENIUM DOPED)
CAS:7440-69-9
RTECS #:EB2600000
Fraction by Wt: 0.2-0.6%
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3
Ingred Name:SUPP DATA: STUDIES.THE MAIN HAZ ASSOCD W/ALLOY IS
POSSIBILITY OF EXPOS TO LEAD DUST/FUMES. OVEREXP TO LEAD OVER (ING
11)
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENTS
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:OVEREXP TO OZONE CAN RSLT IN MUC MEMB
IRRIT, AS WELL AS PULM CHANGES, INCLUDING IRRIT, CONGESTION &
EDEMA. PULM EFT (I.E., EDEMA) CAN BE DELAYED IN ONSET. EXPOS TO
WELDING FUMES CAN CAUSE IRRIT OF EYE S & RESP SYS. ULTRAVIOLET
RADIATION FROM WELDING CAN ALSO CAUSE IRRIT/FLASH BURNS TO EYES &
SKIN. (EFTS OF OVEREXPOS)
Explanation of Carcinogenicity:LEAD (INORGANIC): IARC (GROUP 2B).
Effects of Overexposure:HLTH HAZ: OVEREXP TO COPPER FUME > 2.5% CAN
RSLT IN UPPER RESP TRACT IRRIT, NAUS & METAL FUME FEVER. BERYLLIUM
IS HIGHLY TOX BY INHAL OF FUME/DUST. INHAL OF EXCESSIVE BERYLLIUM
CAN RSLT IN ACUTE PNEUM ONITIS (INFLAMM OF LUNG TISS). CHRONIC
EXPOSURES TO BERYLLIUM BY INHAL IN EXCESS OF ESTABLISHED STANDARDS
(SUPP DATA)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL: IF IRRITATION OR PULMONARY SYMPTOMS DEVELOP, CONSULT
MD. SKIN: IF IRRITATION DEVELOPS, CONSULT MD. EYES: IF IRRITATION
DEVELOPS, CONSULT MD. IMMEDIATELY FLUSH W/POTABLE WATER FOR A
MINIMUM OF 1 5 MINUTES, SEEK ASSISTANCE FROM MD . INGEST: CALL MD
IMMEDIATELY .
===================== Fire Fighting Measures =====================
Extinguishing Media:USE MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:DOES NOT PRESENT A FIRE/EXPLOSION HAZARD
UNDER NORMAL CONDITIONS. SMALL CHIPS, FINE TURNINGS AND DUST MAY
IGNITE READILY.
================== Accidental Release Measures ==================
Spill Release Procedures:COLLECT SCRAP FOR REMELTING.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:ADEQUATE PROTECTIVE CLOTHING SHOULD BE PROVIDED TO
PREVENT CONTAMINATION OF PERSONAL CLOTHING. PERSONNEL ASSIGNED TO
LAUNDER SUCH CLOTHING SHOULD BE ADVISED OF BERYLLIUM'S PRESENCE AND
POTENTIAL HEALT H EFFECTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPRVD RESP PROT WHERE PEL REQMTS
ARE/MAY BE EXCEEDED.SELECT APPROP RESP PROT (HIGH EFFICIENCY
DUST/FUME RESP/SUPPLIED-AIR RESP/ETC.) BASED ON ACTUAL/POTENTIAL
AIRBORNE CONTAMINANTS, TH EIR CONC PRESENT & PROT FACTOR OF RESP.
Ventilation:FUMES/DUST MAY RSLT FROM WORKING W/THESE ALLOYS, PROVIDE
ADEQ GEN & LOC EXHST VENT TO MEET PEL REQMTS FOR BERYLLIUM.
Other Protective Equipment:WELDER'S HELMET. REFER TO OSHA 29 CFR
1910.252 FOR ADDITIONAL PRECS CONCERNING PERSONAL PROT EQUIP &
OTHER SAFETY PRECS.
Work Hygienic Practices:CONSULT OSHA LEAD STANDARD 29 CFR 1910.1025.
Supplemental Safety and Health
PROT:REFER TO OSHA 29 CFR 1910.252 FOR ADDNL PRECS CONCERNING EYE
PROT. HLTH HAZ:CAN PRDCE CHRONIC BERYLLIOSIS (PROGRESSIVE LUNG
DISEASE ) & SYSTEMIC BERYLLIUM DISEASE. INHAL OF BERYLLIUM HAS
PRDCED MULTIPLE SITE TUMORS (E.G.,LUNG TUMORS) IN ANIMAL (ING 9)
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:>970F,>521C
Solubility in Water:NONE
Appearance and Odor:SILVERY SOLID, NO ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WITHOUT ANY SERIOUS INCOMPATIBILITIES.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE WHICH CANNOT BE REUSED OR RECYCLED MAY BE
DISPOSED OF IN A SANITARY LANDFILL. RCRA HAZARDOUS WASTE NO. NOT
FEDERALLY REGULATED. DISPOSE OF I/A/W FEDERAL, STATE AND LOCAL
REGULATIONS .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PR-703
CAGE:DO551
CAGE:83574
CAGE:DO551
============= Composition/Information on Ingredients =============
Ingred Name:POLYSULFIDE RUBBER
Fraction by Wt: 50.0%
Ingred Name:INERT FILLERS(NO ASBESTOS)
Fraction by Wt: 48.0%
Ingred Name:PLASTICIZERS
Fraction by Wt: 2.0%
===================== Hazards Identification =====================
Effects of Overexposure:MAY CAUSE SKIN IRRITATION
======================= First Aid Measures =======================
First Aid:WASH SKIN THOROUGHLY W SOAP & WATER;FLUSH EYES W PLENTY OF
WATER.GET MED ATTN.
===================== Fire Fighting Measures =====================
Flash Point:>200F PMCC
Lower Limits:UNK
Upper Limits:UNK
Extinguishing Media:CO*2,DRY CHEM.
================== Accidental Release Measures ==================
Spill Release Procedures:MOP UP W RAGS/PAPER TOWELS.CLEAN W METHY ETHYL
KETONE USING PROTECTIVE EQUIPMENT.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN CLOSED CONTAINERS IN
SHELTERED AREA.
Other Precautions:AVOID PROLONGED SKIN CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUD
Ventilation:NONE REQD
Other Protective Equipment:CAN USE PROTECTIVE HAND CREAM
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:1.40
Solubility in Water:NEGLIGIBLE
Appearance and Odor:THICK,RED PASTE
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:SOURCE OF IGN.
Hazardous Decomposition Products:HYDROGEN SULFIDE;OXIDES OF SULFUR
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN TIGHTLY CLOSED CONTAINERS IAW
EXISTING REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SHUR-STIK 222 WHITE ACR PRIMER
CAGE:33394
CAGE:33394
============= Composition/Information on Ingredients =============
Ingred Name:SILICA GEL; (AMORPHOUS SILICA)
CAS:63231-67-4
RTECS #:VV7340000
Fraction by Wt: 1-5%
OSHA PEL:80 MG/M3 SIO2
ACGIH TLV:10 MG/M3
Ingred Name:METHANOL (SARA 313) (CERCLA)
CAS:67-56-1
RTECS #:PC1400000
Fraction by Wt: 1-5%
OSHA PEL:200 PPM, S
ACGIH TLV:200 PPM; 250 STEL, S
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:VOLATILE ORGANIC COMPOUND: 180 G/L MAX
RTECS #:9999999VO
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: SKIN: MAY CAUSE SLIGHT
IRRITATION. EYES: MAY CAUSE IRRITATION. INGESTION: MAY CAUSE
GASTROINTESTINAL UPSET, NAUSEA, VOMITING. CHRONIC: NONE KNOWN.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:UNKNOWN.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE
OXYGEN/ARTIFICIAL RESPIRATION) . SKIN: WASH WITH SOAP AND WATER.
EYES: FLUSH WITH LARGE AMOUNTS OF WATER FOR AT LEAST 15 MINUTES.
INGEST: SEEK MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:PRODUCT WILL NOT BURN AS SUPPLIED. DRIED
FILM MAY BURN IF SUBJECT TO SOURCE OF IGNITION.
================== Accidental Release Measures ==================
Spill Release Procedures:SCOOP UP AND RETURN TO CONTAINER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED WHEN NOT IN USE.
STORE IN COOL, DRY AREA. PROTECT FROM FREEZING.
Other Precautions:KEEP OUT OF THE REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NECESSARY. USE NIOSH/MSHA APPROVED
RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:NOT APPLICABLE.
Other Protective Equipment:EYE WASH FOUNTAIN AND DELUGE SHOWER WHICH
MEET ANSI DESIGN CRITERIA .
Work Hygienic Practices:REMOVE CONTAMINATED CLOTHING; LAUNDER BEFORE
REUSE.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>200F,>93C
Vapor Pres:18 @ 25C
Vapor Density:>1
Spec Gravity:1.2
pH:7-9
Evaporation Rate & Reference:<1 (BUAC=1)
Solubility in Water:MISCIBLE
Appearance and Odor:WHITE LIQUID; SWEET ODOR.
Percent Volatiles by Volume:60-80
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:NOT APPLICABLE.
Hazardous Decomposition Products:NOT APPLICABLE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF ACCORDING TO FEDERAL, STATE AND LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MELT BLOWN NON-WOVEN ROLL GOODS
Resp. Party Other MSDS Num.:2084-1.1
CAGE:8V867
Contract Num:SP0450-01-D4077
CAGE:1NKA8
CAGE:8V867
============= Composition/Information on Ingredients =============
Ingred Name:POLYPROPYLENE
CAS:9003-07-0
RTECS #:UD1842000
===================== Hazards Identification =====================
LD50 LC50 Mixture:NO DATA PROVIDED BY RESPONSIBLE PARTY.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Health Hazards Acute and Chronic:ACUTE(SHORT-TERM) HEALTH EFFECTS: NOT
APPLICABLE. CHRONIC (LONG-TERM) HEALTH EFFECTS: NOT APPLICABLE.
TARGET ORGANS: NONE. PRIMARY ROUTES OF ENTRY(EXPOSURE): NONE.
Explanation of Carcinogenicity:NO DATA PROVIDED BY RESPONSIBLE PARTY.
Effects of Overexposure:INHALATION: NOT APPLICABLE. SKIN: NOT
APPLICABLE. ABSORPTION: NOT APPLICABLE. INGESTION: NOT APPLICABLE.
EYE: NOT APPLICABLE.
Medical Cond Aggravated by Exposure:NO DATA PROVIDED BY RESPONSIBLE
PARTY.
======================= First Aid Measures =======================
First Aid:INHALATION: NOT APPLICABLE. SKIN: NOT APPLICABLE. ABSORPTION:
NOT APPLICABLE. INGESTION: NOT APPLICABLE. EYE: NOT APPLICABLE.
===================== Fire Fighting Measures =====================
Flash Point:>316.C, 600.8F
Autoignition Temp:>302.C, 575.6F
Lower Limits:N/D
Upper Limits:N/D
Extinguishing Media:CARBON DIOXIDE(CO2), FOAM, DRY CHEMICAL, OR WATER
SPRAY.
Fire Fighting Procedures:WATER SHOULD BE USED TO KEEP FIRE-EXPOSED
CONTAINERS COOL. WATER OR DRY CHEMICAL USED MAY CAUSE DAMAGE TO
MACHINERY. SELF-CONTAINED BREATHING APPARATUS AND PERSONAL
PROTECTIVE EQUIPMENT SHOULD BE USED AS NECESSARY.
Unusual Fire/Explosion Hazard:NO DATA PROVIDED BY RESPONSIBLE PARTY.
================== Accidental Release Measures ==================
Spill Release Procedures:LAND SPILLS- ELIMINATE SOURCES OF IGNITION.
RECOVER SPILLED MATERIAL & PLACE IN SUITABLE CONTAINERS FOR RECYCLE
OR DISPOSAL. WATER SPILL-SKIM MATERIAL FROM SURFACE & ADVISE
AUTHORITIES IF FLOATING MAT ERIAL ENTERS A WATERCORSE OR SEWER.
PICK UP LARGE PIECES. VACUUM DUSTS. IF SWEEPING IS NECESSARY, USE A
DUST SUPPRESSANT SUCH AS WATER. DO NOT DRY SWEEP DUST OR USE
COMPRESSED AIR FOR CLEANING.
Neutralizing Agent:NO DATA PROVIDED BY RESPONSIBLE PARTY.
======================Handling and Storage ======================
Handling and Storage Precautions:ELECTROSTATIC ACCUMULATION HAZARD. USE
PROPER GROUNDING PROCEDURE. WAREHOUSE STORAGE SHOULD BE IN
ACCORDANCE WITH PACKAGE DIRECTIONS, IF ANY. MATERIAL SHOULD BE KEPT
DRY, AND PROTECTED FROM THE ELEMEN TS.
Other Precautions:NO DATA PROVIDED BY RESPONSIBLE PARTY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT APPLICABLE.
Ventilation:NOT APPLICABLE.
Other Protective Equipment:NO DATA PROVIDED BY RESPONSIBLE PARTY.
Work Hygienic Practices:NO DATA PROVIDED BY RESPONSIBLE PARTY.
Supplemental Safety and Health
NO SPECIFIC PROTECTIVE MEASURES ARE NECESSARY FOR USE OF THESE PRODUCTS
IN THAT THEY ARE ARTICLES, AND UNDER NORMAL CONDITIONS OF USE THEY
ARE NOT EXPECTED TO RELEASE, OR OTHERWISE RESULT IN EXPOSURE TO A
HAZARDOUS CHEMICAL.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:NOT APPLICABLE.
Melt/Freeze Pt:>107.C, 224.6F
Vapor Pres:NEGLIGIBLE
Spec Gravity:VARIES BY GRADE
Evaporation Rate & Reference:NOT APPLICABLE.
Solubility in Water:INSOLUBLE
Appearance and Odor:WHITE MELT BLOWN NON-WOVEN MATERIAL; NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:TEMPERATURES OVER 249C/480F MAY CAUSE
MATERIAL DEGRADATION.
Hazardous Decomposition Products:METHANE, ACETONE, AND OTHER KETONES.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
=================== Toxicological Information===================
Toxicological Information:THIS PRODUCT HAS NOT BEEN TESTED AS A
SEPARATE ENTITY. THEREFORE, THE HAZARDS MUST BE EVALUATED ON THE
BASIS OF THE INDIVIDUAL INGREDIENTS AND THOSE HAZARDS MUST BE
ASSUMED TO BE ADDITIVE IN THE ABSEN CE OF COMPLETE DATA. ACUTE
EFFECTS: THE PRODUCTS ARE NOT EXPECTED TO PRESENT ANY ACUTE
TOXICOLOGICAL EFFECTS IN THAT UNDER NORMAL CONDITIONS OF USE, THEY
WILL NOT RELEASE OR OTHERWISE RESULT IN EXPOSU RE TO HAZARDOUS
CHEMICALS. CHRONIC EFFECTS: NO CHRONIC EFFECTS ARE EXPECTED FROM
THE NORMAL USES OF THIS PRODUCT.
===================== Ecological Information =====================
Ecological:THIS PRODUCT HAS NOT BEEN TESTED.
==================== Disposal Considerations ====================
Waste Disposal Methods:THIS PRODUCT IS NOT REGULATED AS A HAZARDOUS
WASTE BY THE U.S ENVIRONMENTAL PROTECTION AGENCY (EPA) UNDER
RESOURCE CONSERVATION AND RECOVERY ACT(RCRA) REGULATIONS. COMPLY
WITH STATE & LOCAL REGULATION FOR DISPOSAL. IF YOU ARE UNSURE OF
THE REGULATIONS, CONTACT YOU LOCAL PUBLIC HEALTH DEPARTMENT, OR
THE LOCAL OFFICE OF THE EPA.
=================== MSDS Transport Information ===================
Transport Information:THIS PRODUCT IS NOT REGULATED AS A HAZARDOUS
MATERIAL FOR TRANSPORT.
===================== Regulatory Information =====================
SARA Title III Information:THERE ARE NO COMPONENTS IN THIS PRODUCT
REGULATED BY THE ENVIRONMENTAL PROTECTION AGENCY (EPA) UNDER THE
SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT (SARA TITLE III); THE
COMPREHENSIVE ENVIRONMENTAL RESPONSE, COMPENSATION AND LIABILITY
ACT (CERCLA), OR THE TOXIC SUBSTANCE CONTROL ACT (TSCA).
Federal Regulatory Information:TOXIC SUBSTANCE CONTROL ACT INVENTORY
(TSCA 8(B)): THE COMPONENTS OF THIS PRODUCT ARE LISTED.
State Regulatory Information:STATES ENFORCING 1989 AIR CONTAINMMENT
STANDARDS: AK, CA, CT, ME, MT, MN, NM, TN,WA, WI. CADADA EPA
DOMESTIC SUBSTANCE LIST (DSL): THE PRODUCT AND ITS COMPONENTS ARE
LISTED.
======================= Other Information =======================
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:CUSTOM PLASMA STANDARD, PLAG2-3X
Preparer's Name:LINDA PINDILLI
CAGE:07977
CAGE:07977
============= Composition/Information on Ingredients =============
Ingred Name:NO INGREDIENT FOR THIS FORMULATION_INGREDIENT
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SOLN MAY BE HARMFUL IF
INHAL/INGEST/CONT W/SKIN & EYES. EXPOS TO SILVER NITRATE MAY LEAD
TO DISCOLORATION/DISORDERS OF MUC MEMB/NOSE/THROAT/ EYES. LG ACUTE
DOSES OF SILVER NITRATE CAUSES BURNING THROA T/VIOLENT ABDOM
PAIN/VOMIT/COLLAPSE/ DEATH. CHRONIC EXPOS CAN RSLT IN PNEUM/DERMAL/
CORNEAL PROBLEMS. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: CONC NITRIC ACID MAY BE FATAL IF TOO
MUCH IS INHAL/ABSORB THRU SKIN. CONC NITRIC ACID VAP/MIST IS IRRIT
OF EYES/MUC MEMB/SKIN. IN CONT W/EYES, IT PRDCES SEV BURNS WHICH
MAY RSLT IN PERM DMG/ VISUAL IMPAIRMENT. ON THE SKIN, LIQ/CONC VAP
PRDCES IMMED/SEV/PENETRATING BURNS; CONC SOLNS CAUSE DEEP ULCERS
(ING 4)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR AT LEAST 15 MINUTES OCCASIONALLY
LIFTING UPPER/LOWER EYELIDS. SKIN: REMOVE CONTAMD CLTHG, THEN FLUSH
W/WATER FOR AT LEAST 15 MINUTES. WASH CLTHG THOROUGHLY BEFORE
REUSE. INHAL: MOVE TO FRESH AIR. IF IRRITATION CONTINUES, GET
MEDICAL ATTENTION IMMEDIATELY.
===================== Fire Fighting Measures =====================
Extinguishing Media:APPROPRIATE TO SURROUNDING FIRE CONDITIONS.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:CONC HNO*3 REACTS EXPLOSIVELY W/COMBUST
ORGANIC OR READILY OXIDIZABLE MATLS SUCH AS: ALCOHOL, WOOD,
TURPENTINE, METAL POWDERS, HYDROGEN SULFIDE, ETC.(SUPP DATA)
================== Accidental Release Measures ==================
Spill Release Procedures:VENT AREA. DILUTE SPILL W/H*2O & NEUTRALIZE
W/SODA ASH/LIMESTONE/ETC. WIPE UP & PUT INTO A SEALED CONTR FOR
PROPER DISPOSAL. WASH SPILL SITE OFF W/H*2O AFTER MATL PICK UP IS
COMPLETE. WEAR CHEM RESISTPERSONAL PROT & NIOSH/MSHA APPRVD
RESPIRATOR.
Neutralizing Agent:SODA ASH, LIMESTONE, ETC.
======================Handling and Storage ======================
Handling and Storage Precautions:CONCENTRATED NITRIC ACID WILL ATTACK
SOME FORMS OF PLASTICS, RUBBER, & COATINGS. STORE AT ROOM TEMP.
KEEP TIGHTLY SEALED WHEN NOT IN USE.
Other Precautions:HAVE IMMED AVAIL OF AN EYE WASH IN CASE OF EMER.
WARNING! IRRIT/OXIDIZER/CORR LIQ. AVOID INHAL/INGEST/CONT
W/EYES/SKIN. SYMP/HLTH HAZ FOR DILUTE NITRIC ACID ARE EXPECTED TO
BE LESS SEV THAN EXPOS TO C ONC NITRIC ACID. HOWEVER, SINCE (ING 8)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:EXHAUST: USE IN A CHEMICAL FUME HOOD.
Other Protective Equipment:CHEMICAL RESISTANT CLOTHING/LAB COAT.
EMERGENCY EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:WASH CAREFULLY AFTER USE. WASH CONTAMINATED
CLOTHING THOROUGHLY BEFORE REUSE.
Supplemental Safety and Health
EXPLO HAZ: FLAMMABILITY: CONC HNO*2 IS NOT COMBUST, BUT IS STRONG
OXIDIZER & ITS HEAT OF RXN W/REDUCING AGENTS/COMBUST MAY CAUSE
IGNIT. CAN REACT W/METALS TO RELS FLAMM HYDROGEN GAS. MATLS TO
AVOID: A S: ALCOHOL/WOOD/TURPENTINE/METAL PWDRS/HYDROGEN
SULFIDE/ETC. CONT W/STRONG BASES WILL CAUSE VIOLENT SPLATTERING.
================== Physical/Chemical Properties ==================
HCC:C1
Spec Gravity:1
Solubility in Water:SOLUBLE IN WATER
Appearance and Odor:TRANSPARENT WITH AN ACRID ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CONC HNO*3 IS POWERFUL OXIDIZING AGENT. IT REACTS EXPLOS W/COMBUST
ORGANIC OR READILY OXIDIZABLE MATLS SUCH (SUPP DATA)
Stability Condition to Avoid:STABLE UNDER NORMAL STORAGE & USE.
ELEVATED TEMPERATURES MAY CAUSE CONTRS TO BURST & LIBERATE TOXIC
OXIDES OF NITROGEN.
Hazardous Decomposition Products:WILL RELEASE TOXIC NITROGEN OXIDE
FUMES AND VAPORS.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTACT LOCAL, STATE, OR FEDERAL HAZARDOUS OR
CHEMICAL WASTE DISPOSAL AGENCY FOR REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:INSTRU-KLENZ;PRODUCT NO.1086
Preparer's Name:R.C. JENTE
CAGE:19410
CAGE:19410
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM HYDROXIDE (SARA III)
CAS:1310-73-2
RTECS #:WB4900000
Fraction by Wt: <1.0%
Other REC Limits:NONE SPECIFIED
OSHA PEL:2 MG/M3
ACGIH TLV:C 2 MG/M3; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:OTHER COMPONENTS (TYPE NOT SPECIFIED)
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:UNKNOWN Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:MAY CAUSE IRRITATION OF
EYES,SKIN,RESPIRATORY OR G,I.TRACT;REDNESS OR BURNS OF EYES ARE
POSSIBLE.
Explanation of Carcinogenicity:DATA PER MGF MSDS.
Effects of Overexposure:SEE HEALTH HAZARDS DATA.
Medical Cond Aggravated by Exposure:NONE EXPECTED UNDER NORMAL USE AS
DIRECTED.USE WITH AN ADEQUATE VENTILATION.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH WITH WATER 15 MINUTES,CALL PHYSICIAN. SKIN: WASH
WITH SOAP & WATER,CALL PHYSICIAN IF IRRITATION DEVELOPS. INGESTION:
DRINK 1-2 GLASSES WATER,INDUCE VOMITING,REPEAT UNTIL VOMIT IS
CLEAR,CALLPHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:USE ANY MEDIA LIKE WATER FOG, CARBON DIOXIDE, FOAM,
OR DRY CHEMICAL IF APPLICABLE.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED
CONTAINERS WITH WATER SPRAY. CONTAIN RUNOFF.
Unusual Fire/Explosion Hazard:NONE EXPECTED
================== Accidental Release Measures ==================
Spill Release Procedures:STOP LEAK, CONFINE SPILL. COLLECT SPILLAGE
USING ABSORBENT MATERIAL, PLACE IN CLOSABLE CONTAINER. FLUSH
RESIDUE TO SEWER W/AMPLE WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY AND WELL VENTILATED
AREA.KEEP CONTAINER CLOSED WHEN NOT IN USE.
Other Precautions:WASH THOROUGHLY AFTER EACH USE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NEEDED WITH AN ADEQUATE VENTILATION.
Ventilation:NORMAL ROOM VENTILATION.
Other Protective Equipment:PROTECTIVE CLOTHINGS.EYE-WASH
FACILITIES,SAFETY SHOWER.
Work Hygienic Practices:AVOID CONTACT WITH EYES AND SKIN;DO NOT BREATHE
VAPORS/MIST/DUST.WASH THOROUGHLY AFTER EACH USE;DO NOT
EAT,DRINK,SMOKE.
Supplemental Safety and Health
PRODUCT NO. IS 1086.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:>212F/>100C
Vapor Pres:18 (WATER)
Vapor Density:1.0(WATER)
Spec Gravity:1.1
pH:<12.0
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR TO YELLOWISH LIQUID MILD CHEMICAL ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS, STRONG OXIDIZERS, ALUMINUM.
Stability Condition to Avoid:EXTREMELY HIGH TEMPERATURES
Hazardous Decomposition Products:CONTACT WITH ALUMINUM MAY PRODUCE
HYDROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONSULT LOCAL AUTHORITIES;DISPOSAL MUST BE IN
ACCORDANCE WITH LOCAL,STATE AND FEDERAL REGULATIONS
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:11700050 PEEL MASK
Preparer's Name:WERNER A.EHRENSCHNEIDER
CAGE:DO645
CAGE:11924
CAGE:DO645
============= Composition/Information on Ingredients =============
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 60%
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:DIMETHYL SILOXANE
CAS:63148-62-9
RTECS #:JT6484500
Ingred Name:MFR STATES,"TRADE SECRET INFO WILL BE DISCLOSED ONLY UPON
FULL COMPLIANCE WITH OSHA STD, 29 CFR 1910.1200."
RTECS #:9999999ZZ
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:PRODUCT IS IRRITATING TO BODY
TISSUES. MAY CAUSE DROWSINESS AND IRRITATE NOSE & THROAT. LARGE
AMOUNTS CAN CAUSE SERIOUS INJURY. CHRONIC: REPEATED & PROLONGED
SKIN CONTACT CAUSES SERIOUS IRRITATI ON & BURNS. VAPORS MAY INJURE
LUNGS, LIVER, KIDNEY & CENTRAL NERVOUS SYSTEM.
Explanation of Carcinogenicity:MFR LISTS NO INGREDIENT THAT IS LISTED
BY IARC, NTP OR OSHA AS A CARCINOGEN.
Effects of Overexposure:OVEREXPOSURE MAY LEAD TO EYE, SKIN &
RESPIRATORY TRACT IRRITATION. VAPORS MAY CAUSE DIZZINESS,
HEADACHES, NAUSEA, AND SKIN/EYE IRRITATION. INHALING LIQUID WHILE
VOMITING CAN SERIOUSLY INJURE LUNGS. MA Y BURN OR BE ABSORBED
THROUGH SKIN DURING PROLONGED OR REPEATED CONTACT, CAUSING SERIOUS
INTERNAL INJURY.
Medical Cond Aggravated by Exposure:PERSONS WITH EXISTING EYE, SKIN,
AND RESPIRATORY DISORDERS MAY BE AT INCREASED RISK WHEN HANDLING OR
USING THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH W/WATER 15 MIN, HOLD LIDS OPEN. SKIN:WASH WITH
SOAP & WATER. REMOVE CONTAMINATED CLOTHING AND LAUNDER BEFORE
REUSE. INHALED:REMOVE TO FRESH AIR. RESTORE BREATHING IF
NECESSARY.INGESTED:D O NOT INDUCE VOMITING. GIVE 2 LARGE GLASSES
OF MILK OR WATER AND GET IMMEDIATE MEDICAL CARE. GIVE NOTHING BY
MOUTH IF UNCONSCIOUS. IF IRRITATION PERSISTS OR IS SEVERE,SEE A
DOCTOR.
===================== Fire Fighting Measures =====================
Flash Point Method:TOC
Flash Point:41.0F,5.0C
Lower Limits:1.2
Upper Limits:7
Extinguishing Media:USE CARBON DIOXIDE, FOAM, OR DRY CHEMICAL.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY CAUSE
CONTAINERS TO BURST, EXPOSING HIGHLY FLAMMABLE CONTENTS.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE SOURCES OF IGNITION. USE ABSORBENT
MATERIAL TO COLLECT AND CONTAIN FOR SALVAGE OR DISPOSAL. VENTILATE
AREA.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED AND AWAY FROM
HEAT, SPARKS, AND OPEN FLAME. FLAMMABLE LIQUID; EMPTY CONTAINERS
MAY CONTAIN HAZARDOUS VAPORS AND RESIDUES.
Other Precautions:ALLOW EMPTY CONTAINER TO DRY IN A WELL VENTILATED
AREA FREE OF IGNITION SOURCES BEFORE DISPOSAL
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESPIRATOR WILL NOT NORMALLY BE NECESSARY. USE
NIOSH/MSHA APPROVED AIR SUPPLIED RESPIRATOR OR RESPIRATOR FOR
ORGANIC DUST/VAPOR IF EXPOSURE IS ABOVE THE TLV/PEL. SEE 29 CFR
1910.134 FOR REGULATIONS P ERTAINING TO RESPIRATOR USE.
Ventilation:LOCAL AND MECHANICAL(GENERAL) ARE BOTH RECOMMENDED. AVOID
OPEN ELECTRICAL IGNITION SOURCES NEAR PRODUCT VAPOR AREAS.
Other Protective Equipment:EYE WASH STATION & SAFETY SHOWER. WEAR
INDUSTRIAL TYPE WORK CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:USE GOOD CHEMICAL HYGIENE PRACTICE. AVOID
UNNECESSARY CONTACT.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F2
Spec Gravity:1.0-1.04
Evaporation Rate & Reference:SLOWER THAN ETHYL ETHER
Solubility in Water:NEGLIGIBLE
Appearance and Odor:THICK BLUE PAINT,STRONG SOLVENT ODOR
Percent Volatiles by Volume:60
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH TEMPERATURES, SPARKS, AND OPEN FLAMES
Hazardous Decomposition Products:TALC DUST AND CARBON DIOXIDE AND OTHER
TRACES OF INCOMPLETELY BURNED CARBON PRODUCTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE I/A/W ALL FEDERAL, STATE AND LOCAL
REGULATIONS. DISPOSAL MAY BE DONE BY INCINERATION.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:FM 300K/FM 300/FM 300-1 ADHESIVE FILMS
Preparer's Name:MARVIN A FRIEDMAN
CAGE:07542
CAGE:07542
============= Composition/Information on Ingredients =============
Ingred Name:TITANIUM DIOXIDE, TIO2
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 0-0.5%
OSHA PEL:15 MG/CUM
ACGIH TLV:10 MG/CUM (DUST)
Ingred Name:FIBROUS (FIBER) GLASS, OXIDE GLASS, GLASS FIBERS
RTECS #:LK3651000
Fraction by Wt: 0-20%
Other REC Limits:3000000 FB/CUM
OSHA PEL:15 MG/CUM
ACGIH TLV:10 MG/CUM
Ingred Name:GRAPHITE*93-4*
CAS:7782-42-5
RTECS #:MD9659600
Fraction by Wt: 0-20%
Other REC Limits:2.5MG/CUM
ACGIH TLV:2 MG/CUM RESP IC
===================== Hazards Identification =====================
LD50 LC50 Mixture:ACUTE LD50 (RABBIT): >2 G/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: ALLERGIC REACTIONS, PRIMARY
IRRITATION BY PROLONGED/REPEATED CONTACT. INHALATION: REPIRATORY
TRACT IRRITATION/INJURY. EYES: IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION
======================= First Aid Measures =======================
First Aid:SKIN: WASH AFFECTED AREAS W/SOAP & WATER. EYES: IRRIGATE
W/PLENTY OF WATER FOR 15 MINUTES. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER, CO2, DRY CHEMICAL .
Fire Fighting Procedures:WEAR SCBA IN POSITIVE PRESSURE MODE & FULL
PROTECTIVE CLOTHING.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR NIOSH APPROVED, POSITIVE PRESSURE, SELF
CONTAINED RESPIRATOR & PROTECTIVE EQUIPMENT. SWEEP UP & PLACE IN A
WASTE DISPOSAL CONTAINER. FLUSH AREA W/WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID PROLONGD/REPEATED CONTACT
W/SKIN. STORE AT/BELOW 0F.
Other Precautions:CUTTING, GRINDING/SANDING OF PARTS FABRICATED AFTER
CURING MAY CREATE RESPIRABLE DUST PARTICLES. RESPIRATORY PROTECTION
APPROPRIATE FOR THIS DUST MAY BE REQUIRED. FOODS, BEVERAGES &
TOBACCO PRODUCTS S HOULDN'T BE USED/STORED NEAR PRODUCT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED RESPIRATOR WHERE EXPOSURES EXCEED
PELS.
Ventilation:LOCAL EXHAUST WHERE SPRAYING/CURING AT ELEVATED TEMPS.
Other Protective Equipment:IMPERVIOUS APRONS/PANTS/LONG SLEEVE
SHIRT/EYEWASH & SAFETY SHOWER, BARRIER CREAMS/DISPOSABLE
COVERALLS/FACE SHIELD
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. REMOVE/LAUNDER
CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Vapor Pres:NEGLIGIBLE
Spec Gravity:1.3-1.4
Solubility in Water:NEGLIGIBLE
Appearance and Odor:FILM W/YELLOW GREENISH COLOR, SLIGHTLY TACKY W/NO
ODOR
Percent Volatiles by Volume:<1/WT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG BASES, STRONG ACIDS
Stability Condition to Avoid:TEMP >70F
Hazardous Decomposition Products:CO/CO2
Conditions to Avoid Polymerization:POLYMERIZATION MAY OCCUR SLOWLY AT
ROOM TEMPERATURE. STORE AT/BELOW 0F TO PROLONG SHELF LIFE.
==================== Disposal Considerations ====================
Waste Disposal Methods:HEAT CURING PRIOR TO DISPOSAL IS RECOMMENDED.
DISPOSE OF IAW/FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Preparer's Name:DOD HMIS/DGSC-SSH
CAGE:JO772
CAGE:14153
CAGE:JO772
============= Composition/Information on Ingredients =============
Ingred Name:ASBESTOS, CHRYSOTILE
CAS:12001-29-5
RTECS #:CI6478500
OSHA PEL:0.2 FIBERS/CC
ACGIH TLV:2 FIBERS/CC; A1;9192
Ingred Name:ASBESTOS & STEEL
RTECS #:9999999ZZ
Ingred Name:GENERIC "MSDS". SPECIFIC ASBESTOS TYPE NOT KNOWN. ONE
CITED IS ASSUMED. INFORMATION BASED ON SEGMENT "M" OF "DLSC TIR"
RTECS #:9999999ZZ
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: NO ACUTE EFFECTS ARE KNOWN;
CHRONIC: DUST FROM ABRASIVE ACTIONS(EG. CUTTING, MACHINING,
FILING, ETC.) MAYCONTAIN ASBESTOS FIBERS. CHRONIC OVEREXPOSURE
TO AIRBORNE FIBERS MAY LEAD TO ASBESTOSIS & MESOTHELIOMA.
SMOKINGCOMBINED W/FIBER INHALATION GREATLY INCREASES LUNG
CANCER RISK!
Explanation of Carcinogenicity:OVEREXPOSURE TO AIRBORNE CONCENTRATIONS
OF ASBESTOS MAY LEAD TO ASBESTOSIS AND MESOTHELIOMA.
Effects of Overexposure:INHAL: INHALATION OF AIRBORNE DUST CONTAINING
ASBESTOS FIBERS ON REPEATED EXPOSURE MAY CAUSE OR CAN LEAD TO
ASBESTOSIS/ MESOTHELIOMA; SKIN: N/K; EYE: POTENTIAL IRRITATION
FROM AIRBORNE DUST; INGEST: N/K.
Medical Cond Aggravated by Exposure:RESPIRATORY DEFICIENCIES DUE TO
REPEATED INHALATION OF AIRBORNE FIBERS.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. OBTAIN MEDICAL ADVICE; SKIN:
WASH EXPOSED AREA WITH SOAP & WATER; EYE: FLOOD W/ WATER. IF
IRRITATION OCCURS, GET MEDICAL ATTN; INGEST: CONSULT A
PHYSICIAN; OTHER: CHANGE CLOTHING AS REQUIRED TO AVOIDCARRYING
DUST PARTICLES INTO OTHER AREAS
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:MATERIAL IS NOT FLAMMABLE ; USE MEDIA APPROPRIATE
FOR SURROUNDING FIRE.
Fire Fighting Procedures:COMBUSTION PRODUCTS OF THIS MATERIAL MAY BE
TOXIC. USE A SELF-CONTAINED BREATHING APPARATUS WHEN FIGHTING FIRES
INVOLVING CHEMCIAL PRODUCTS.
Unusual Fire/Explosion Hazard:NONE KNOWN
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION. VACUUM OR WET
CLEAN IF DUST IS INVOLVED. ANY VACUUM SYSTEM SHOULD BE EQUIPPED W/
AN OUTLET "HEPA" FILTER TO PREVENT REINTRODUCING ASBESTOS FIBERS TO
THE ATMOSPHERE.
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLE IN A MATTER TO MINIMIZE
FORMATION OR RETENTION OF AIRBORNE DUST. USE PROPER PERSONAL
PROTECTION FOR TASK AT HAND. CHECK W/YOUR SAFETY OFFICE!!!
Other Precautions:AS MANUFACTURED, LOCKED-IN ASBESTOS DOES NOT PRESENT
A HAZARD. ONLY WHEN THE ITEM IS SUBJECTED TO ABRASIVE ACTIONS &
DUST IS GENERATED, THEN ASBESTOS FIBERS MAY BE RELEASED & BECOME
AIRBORNE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF EXPOSURES EXCEED ESTABLISHED LIMITS, A
NIOSH/MSHA APPROVED RESPIRATOR FOR ASBESTOS SHOULD BE USED.
CONSULT YOUR SAFETY OFFICE/IH PERSONNEL FOR GUIDANCE FOR THE TASK
AT HAND.
Ventilation:LOCAL EXHAUST IS RECOMMENDED IN SITUATIONS WHERE DUST IS
GENERATED BY ABRASIVE ACTIONS, ABRASION OR OTHER MEANS.
Other Protective Equipment:AS REQUIRED FOR TASK AT HAND, AND THE
GUIDANCE SET FORTH BY YOUR SAFETY OFFICE OR IH PERSONNEL
Work Hygienic Practices:DONOT INHALE DUST CREATED BY ABRADING ACTIONS.
USE FULL PROTECTION AGAINST AIRBORNE FIBERS. AVOID AIRBORNE DUST
CREATION
Supplemental Safety and Health
GENERIC "MSDS" CREATED FOR "NSN" IDENTIFIED BY "DISC" AS CONTAINING
ASBESTOS.WHEN A MANUFACTURER'S SPECIFIC "MSDS" IS PROVIDED FOR
MATERIAL PROCURED UNDER THIS NSN, THIS GENERIC "MSDS" WILL BE
REMOVED.
================== Physical/Chemical Properties ==================
HCC:T6
Evaporation Rate & Reference:NONE
Solubility in Water:NOT SOLUBLE
Appearance and Odor:MANUFACTURED COMMODITY DESCRIBED BY LOGISTICS:
"ITEM-NAME"
Percent Volatiles by Volume:NONE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:NONE KNOWN
==================== Disposal Considerations ====================
Waste Disposal Methods:DUST SHOULD BE HANDLED AS A HAZARDOUS AIR
POLLUTANT I/A/W 40CFR61 SUBPART "M" PERTAINING TO ASBESTOS. USE
LANDFILLS APPROVED FOR ASBESTOS DISPOSAL. NOTE IF ITEM UNDER
CONSIDERATION FOR DISPOSAL IS "FRIABLE OR NON-FRIABLE".
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:GRAY
CAGE:33200
CAGE:33200
============= Composition/Information on Ingredients =============
Ingred Name:ALKYD RESIN
Fraction by Wt: 7.0%
Ingred Name:PETROLEUM DISTILLATES (NAPHTHA OR RUBBER SOLVENT)
CAS:8002-05-9
RTECS #:SE7449000
Fraction by Wt: 28.0%
OSHA PEL:400 PPM
ACGIH TLV:400 PPM; 8990
===================== Hazards Identification =====================
Effects of Overexposure:PRODUCES SEVERE IRRITATION DRYING OF SKIN
EXCESSIVE INHALATION CAUSES HEADACHE,DIZZINESS,NAUSEA.
======================= First Aid Measures =======================
First Aid:EYE CONTACT FLUSH W/WATER,SKIN CONTACT:WASH W/MILD SOAP &
WATER & APPLY SKIN CREAM. INHALATION REMOVE TO FRESH AIR AND CALL
MD. APPLY ARFIFICIAL RESPIRATION,IF NECESSARY.
===================== Fire Fighting Measures =====================
Flash Point:102 F SETA
Lower Limits:0.8
Upper Limits:5.0
Extinguishing Media:FOAM CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:TREAT AS CLASS B FIRE
Unusual Fire/Explosion Hazard:VAPOR MAY EXPLODE WHEN MIX WITH AIR
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR A RESPIRATOR FLUSH WITH WATER INTO
RETAINING AREA OR CONTAINER. AVOID EXPOSURE TO SPARKS. FIRE OR HOT
METAL SURFACE.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FORM HEAT,SPARKS,OPEN
FLAME.UE WITH ADEQUATE VENTILATION.AVOID PROLONGED OR REPEATED SKIN
CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SELF CONTAINED NIOSH APPROVED RESPIRATOR IF
NECESSARY.
Ventilation:LOCAL EXHAUST TO MAINTN BELOW TLV.
Other Protective Equipment:EYE BATH & SAFETY SHOWER
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:315F (157C)
Vapor Pres:80
Vapor Density:4.9
Spec Gravity:0.903
Evaporation Rate & Reference:SLOWER THAN NBUACT
Solubility in Water:NEGLIGIBLE
Appearance and Odor:PETROLEUM DISTILLATE ODOR GRAY OPAQUE LIQUID
Percent Volatiles by Volume:64.0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:EXCESSIVE HEAT,SPARK,OPEN FLAMES.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY YIELD CARBON
MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:LANDFILL,INCINERATION UNDER SUPERVISED
CONDITIONS.
| 1 | gloves_mandatory |
=======================================================
Product ID: TEC II MOTOR OIL, 10W-30
Cage: 40310
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 40310
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: NO
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: INHAL:VAPOR PRESSURE IS VERY LOW. VAPOR INHALATION UNDER
AMBIENT TEMPERATURE CONDITIONS IS NOT NORMALLY A PROBLEM. SKIN:PROLONGED OR
REPEATED CONTACT MAY CAUSE IRRITATION. EYE:SLIGHT IRRITATION. INGES
T:RELATIVELY NON-TOXIC.
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: EYE:FLUSH W/CLEAR WATER FOR AT LST 15 MINS/UNTIL IRRIT SUBSIDES. IF
IRRIT PERSISTS, CALL MD. SKIN:REMOVE ANY CONTAM CLTHG & WASH SKIN THORO
W/SOAP & WATER. INGEST:DO NOT INDUCE VOMIT; CALL MD IMMED. I NHAL:IMMED
REMOVE FROM EXPOS & CALL MD.ADMIN OXYGEN, IF AVAIL. IF OVER-EXPOSED TO
OIL MIST, REMOVE FROM FURTHER EXPOS UNTIL EXCESSIVE MIST OIL CONDITION
SUBSIDES.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: REPORT SPILLS AS REQD TO APPROP AUTHS. U.S. COAST
GUARD REGS REQ IMMED REPORTING OF SPILLS THAT COULD REACH ANY WATERWAY INCL
INTERMITTENT DRY CREEKS. REPORT SPILL TO COAST GUARD TOLL FREE NUMBER 800-
424-8802. RECOVER FREE PROD. ADD SAND,
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS (FP N).
Handling And Storage Precautions: USE PROD W/CAUT AROUND HEAT, SPKS, PILOT
LIGHTS, STATIC ELEC & OPEN FLAME. KEEP CNTNRS & STOR CNTNRS CLSD WHEN
NOT IN USE.
Other Precautions: DO NOT STORE NEAR HEAT, SPKS, FLAME/STRONG OXIDANTS. "EMPTY"
CNTNRS RETAIN RESIDUE (LIQ &/OR VAP) & CAN BE DANGEROUS. DO NOT
PRESSURIZE, CUT, WELD, BRAZE, SOLDER, DRILL, GRIND/EXPOSE SUCH CNTNRS TO HE
AT, FLAME, SPKS/OTHER SOURCES OF
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: COC
Flash Point Text: >390F,>199C
Lower Limits: 0.9%
Upper Limits: 7%
Extinguishing Media: FOAM, WATER SPRAY (FOG), DRY CHEM, CARBON DIOXIDE &
VAPORIZING LIQ TYPE EXTING AGENTS MAY ALL BE SUITABLE FOR (SUPDAT)
Fire Fighting Procedures: USE NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP (FP
N). PLAN FIRE PROT & RESPONSE STRATEGY THRU CONSULTATION W/LOC FIRE PROT
AUTHS/APPROP SPECIALISTS. USE (SUPDAT)
Unusual Fire/Explosion Hazard: NONE.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE
OF CONCERN (FP N). NO SPECIAL REQUIREMENTS UNDER ORDINARY CONDITIONS OF USE
& W/ADEQUATE VENTILATION.
Ventilation: NO SPECIAL REQUIREMENTS UNDER ORDINARY CONDITIONS OF USE.
Other Protective Equipment: EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET ANSI
DESIGN CRITERIA (FP N).
Work Hygienic Practices: REMOVE CONTAM CLTHG; LAUNDER/DRY CLEAN BEFORE REUSE.
REMOVE CONTAM SHOES & THORO CLEAN BEFORE REUSE; DISCARD IF
Supplemental Safety and Health: NOTE:USERS OF "L" VERSION SHOULD CONSULT "LR"
VERSION FOR ADDNL INFO (FP N). SPEC GRAV:0.8762-0.8899 (H*2O=1). EXTING
MEDIA:EXTING FIRES INVOLVING THIS TYPE OF PROD, DEPENDING ON SIZE/POTNTL SIZE
OF F IRE & CIRCUMSTANCES RELATED TO SITUATION. FIRE FIGHT PROC:WATER TO
KEEP FIRE-EXPOS CNTNRS COOL. IF LEAK/SPILL HAS
=======================================================
Physical/Chemical Properties
=======================================================
Vapor Pres: NEGLIGIBLE
Vapor Density: HVR/AIR
Spec Gravity: SUPP DATA
Evaporation Rate & Reference: NEGLIGIBLE
Solubility in Water: NEGLIGIBLE (
Appearance and Odor: CLEAR, DARK AMBER LIQUID; MILD, BLAND PETROLEUM ODOR.
Percent Volatiles by Volume: NEGLIG
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: AVOID HEAT & OPEN FLAMES.
Materials To Avoid: AVOID OXIDIZING MATERIALS.
Hazardous Decomposition Products: THERMAL DECOMP PRODS ARE HIGHLY DEPENDENT ON
COMBUST CNDTNS. COMPLEX MIXT OF AIRBORNE SOLID, LIQ, PARTICULATES &
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: TEC II MOTOR OIL, 10W-30
Cage: 40310
Company Name: DRYDEN OIL CO INC
Street: 9300 PULASKI HWY
Zipcode: 21220
Label Required IND: Y
Date Of Label Review: 03/27/1995
Status Code: C
Label Date: 03/27/1995
Origination Code: G
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: ACUTE:SKIN:PROLONGED OR REPEATED CONTACT MAY CAUSE
IRRITATION. EYE:SLIGHT IRRITATION. CHRONIC:NONE LISTED BY MANUFACTURER.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MHB-BK SILICONE SEALANT
Preparer's Name:D. LORENZEN
CAGE:MECHA
CAGE:MECHA
============= Composition/Information on Ingredients =============
Ingred Name:METHYLTRIACETOXYSILANE.
CAS:4253-34-3
RTECS #:VV4500000
Fraction by Wt: 5%
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:10 PPM MFR
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 ORAL >10,000 MG/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:N/K
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES:IRRITATION.SKIN:IRRITATION.INGESTION:MAY
CAUSE GASTRIC DISTRESS.INHALATION:MILD RESPIRATORY
IRRITATION.ACETIC ACID RELEASED DURING CURING.
======================= First Aid Measures =======================
First Aid:EYES:IMMEDIATELY FLUSH WITH LOTS OF WATER FOR AT LEAST 15
MINUTES AND GET MEDICAL ATTENTION.SKIN:CLEAN BY COMPLETELY REMOVING
WITH A DRY CLOTH OR PAPER TOWEL BEFORE WASHING WITH DETERGENT AND
WATER.IN GESTION:CALL MD IMMEDIATELY .INHALATION:REMOVE TO FRESH
AIR.SUPPORT BREATHING (GIVE O*2/ARTIFICIAL RESPIRATION .
===================== Fire Fighting Measures =====================
Flash Point Method:TOC
Flash Point:>400F,>204C
Extinguishing Media:ALL STANDARD FIREFIGHTERS MEDIA.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:HAZARDOUS DECOMPOSITION PRODUCTS:CARBON
MONOXIDE,CARBON DIOXIDE,SILICON DIOXIDE ACETIC ACID.
================== Accidental Release Measures ==================
Spill Release Procedures:WIPE OR SOAK UP IN AN INERT MATERIAL AND PUT
IN A CONTAINER FOR DISPOSAL.WASH WALKING SURFACES WITH DETERGENT
AND WATER TO REDUCE SLIPPING HAZARD.WEAR PROPER PROTECTIVE
EQUIPMENT.
Neutralizing Agent:N/K
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTACT WITH SKIN AND
EYES.CONTACT LENS WEARERS MUST NOT HANDLE LENSES WITH CONTAM
FINGERS.USE IN WELL VENTILATED AREA.
Other Precautions:N/K
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL AND GENERAL VENTILATION NECESSARY TO KEEP AIR
CONCENTRATIONS BELOW TLV .
Other Protective Equipment:EYE WASH STATION.
Work Hygienic Practices:AVOID CONTACT WITH SKIN,EYES,CONTACT LENSES.
Supplemental Safety and Health
DENSITY:1066.4 KG/CUM.
================== Physical/Chemical Properties ==================
Decomp Temp:Decomp Text:N/K
Vapor Pres:NEGLIGIBLE
Vapor Density:NEG(AIR=1)
Spec Gravity:1.07 (WATER=1)
Evaporation Rate & Reference:<1 (BUTYL ACETATE=1)
Solubility in Water:INSOLUBLE (20C,68F)
Appearance and Odor:BLACK PASTE,VINEGAR ODOR.
Percent Volatiles by Volume:<5
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:CARBON MONOXIDE,CARBON DIOXIDE,SILICON
DIOXIDE,ACETIC ACID.
Conditions to Avoid Polymerization:WILL NOT OCCUR
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH
FEDERAL,STATE AND LOCAL REGULATIONS .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:Z3030 ZINC ACETATE (CATALOG #:Z1045,Z1200)
Preparer's Name:E. BRULL
CAGE:63415
CAGE:63415
============= Composition/Information on Ingredients =============
Ingred Name:ZINC ACETATE
CAS:5970-45-6
RTECS #:ZG8750000
Fraction by Wt: 100%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:NOT AVIALABLE.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:VERY SLIGHTLY TO SLIGHTLY
DANGEROUS IN CASE OF SKIN CONTACT (IRRIT),OF EYE CONTACT(IRRIT),OF
INGESTION,OF INHAL.PRODUCT MAY IRRIT EYES/SKIN UPON
CONTACT.CHRONIC:THERE'S NO KNOWN EFFECT FROM CHRO NIC EXPO TO
PRODUCT.
Explanation of Carcinogenicity:PER MSDS:CARCINOGENIC EFFECTS:NOT
AVAILABLE.
Effects of Overexposure:VERY SLIGHTLY TO SLIGHTLY DANGEROUS IN CASE OF
SKIN CONTACT (IRRIT),OF EYE CONTACT (IRRIT),OF INGESTION, OF
INHALATION. EYE/SKIN IRRIT.
Medical Cond Aggravated by Exposure:REPEATED OR PROLONGED EXPOSURE IS
NOT KNOWN TO AGGRAVATE MEDICAL CONDITION.
======================= First Aid Measures =======================
First Aid:EYE:IMMED FLUSH W/RUNNING H2O @LEAST 15MINS KEEP EYELIDS
OPN.COLD H2O MAY BE USED.SKIN:CHEM ONTO CLOTH REMOVE CONTAM CLOTH
AS QUICKLY AS POSSIBLE,PROTECT HANDS/BODY.PLACE VICTIM UNDER DELUGE
SHOWER.GE NTLY/WELL WASH CONTAM SKIN W/RUNNING H2O/NON-ABRASIVE
SOAP/CAREFUL TO CLEAN FOLDS/CREVICES/CREASES/GROIN.COVER IRRIT SKIN
W/EMOLLIENT.IRRIT PERSIST GET MED ATTN.INHAL:VICTIM REST IN WELL
VENTI (SUPPL)
===================== Fire Fighting Measures =====================
Flash Point:NOT AVAILABLE
Autoignition Temp:Autoignition Temp Text:N/AVAI
Lower Limits:N/AVAI
Upper Limits:N/AVAI
Extinguishing Media:SMALL FIRE:USE DRY CHEMICALS,CO2,WATER SPRAY OR
FOAM.LG FIRE:USE WATER SPRAY,FOG,OR FOAM.DONT USE WATER JET.
Fire Fighting Procedures:DONT USE WATER JET.
Unusual Fire/Explosion Hazard:FLAMM OF PROD:COMBUST.NO SPEC INFO AVAI
IN DATABASE REGARDING FLAMM OF PROD IN PRESENCE OF VAR MATLS.RISK
EXPLO W/MECH IMPACT/STATIC DISCHARGE:N/AVAI.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL:USE APPROP TOOLS TO PUT SPILL SOLID IN
CONVENIENT WASTE DISPO CNTNR.FINISH CLEANUP BY SPREADING H2O ON
CONTAM SURF.DISPO OF ACCORDING TO LOC/REGIONAL AUTHORITY
REQMTS.LG:OUR DATABASE CONTAINS NOADDN INFO.USE SHOVEL TO PUT
MATL INT (SUPPLE)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FRM HEAT/IGN SOURCES.EMPTY
CNTNR POSE FIRE RISK,EVAPORATE RESIDUE UNDER FUME HOOD.GROUND ALL
EQPMT CONTAIN MATL.KEEP CNTNR DRY,IN COOL PLACE
Other Precautions:KEEP CNTNR TIGHTLY CLSD.,IN COOL WELL-VENTI
PLACE.COMBUST MATL SHOULD BE STORED AWAY FROM EXTREME HEAT/AWAY FRM
STRONG OXIDIZING AGENTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR APPROPRIATE RESPIRATOR WHEN VENTILATION IS
INADEQUATE. VENTILATION:IF USER OPERATIONS GENERATE DUST/FUME/MIST
USE VENTILATION TO KEEP EXPO TO AIRBORNE CONTAM BEL EXPO LIMIT.
Ventilation:USE PROCESS ENCLOSURE,LOC EXHAU VENTIKOTHER ENGINEER
CNTRL-KEEPS AIRBORNE LEVELS BEL RECOMMENDED EXPO LIMIST.(CONT RESP)
Other Protective Equipment:LAB COAT,FULL SUIT,BOOTS.SUGGESTED
PROTECTIVE CLOTHING MIGHT NOT BE SUFFICIENT;CONSULT SPECIALIST
BEFORE HNDLG PRODUCT.
Work Hygienic Practices:WASH CONTAM CLOTH BEF REUSING.DONT
INGEST/BREATHE DUST.INGEST SEEEK MED AVICE IMMED,SHOW CNTNR/LABEL.
Supplemental Safety and Health
1STAID:AREA.GET IMMED MED ATTN.INGEST:REMOVE DENTURES IF ANY.WATCH FOR
OBSRUCTION IN MOUTH,REMOVE BUT DONT FORCE FINGERS/HARD OBJ BETWEEN
TEETH.HAVE CONSC PERSON DRINK SEVERAL GLASSES OF H2O/MILK.INDU CE
VOMIT BY STICKING FINGER IN THROAT.GET IMMED MED ATTN.
SPILL:CONVENIENT WASTE DISPO CNTNR.
================== Physical/Chemical Properties ==================
HCC:C3
Boiling Pt:B.P. Text:N/AVAI
Melt/Freeze Pt:M.P/F.P Text:DECOMPOSES
Decomp Temp:Decomp Text:NP
Vapor Pres:N/AVAI
Vapor Density:N/AVAI
Spec Gravity:1.735
pH:N/AVAI
Viscosity:NP
Evaporation Rate & Reference:NP
Solubility in Water:(SEE APPEARANCE)
Appearance and Odor:SOLID, COLOR/ODOR/TASTE:NOT AVAILABLE. EASILY
SOLUBLE IN HOT H2O,SOLUBLE IN COL
Percent Volatiles by Volume:N/AVAI
Corrosion Rate:NP
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NO SPECIFIC INFO AVAIL ON OUR DATABASE REGARDING REACTIVITY OF THIS
MATL IN PRESENCE OF VARIOUS OTHER MATLS.
Stability Condition to Avoid:NO ADDITIONAL REMARK
Hazardous Decomposition Products:THESE PRODUCTS ARE CARBON OXIDES (CO,
CO2).SOME METALLIC OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:PRODUCTS OF DEGRADATION ARE MORE TOXIC.RECYCLE
TO PROCESS IF POSSIBLE.CONSULT YOUR LOCAL OR REGIONAL AUTHORITIES.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ENAMEL ALKYD, GLOSS BROWN 10076, ID: 742010
Preparer's Name:W.A. ELLISON
CAGE:FO127
CAGE:FO127
CAGE:61196
============= Composition/Information on Ingredients =============
Ingred Name:VM&P NAPHTHA (LIGROINE)
CAS:8032-32-4
RTECS #:OI6180000
OSHA PEL:300 PPM/400 STEL
ACGIH TLV:300 PPM; 9192
Ingred Name:LEAD CHROMATE
CAS:7758-97-6
OSHA PEL:.0500 MG/CU.M.
ACGIH TLV:.0500 MG/CU.M.
Ingred Name:MINERAL SPIRITS
(VAPOR PRESSURE 2 MMHG @ 20C)
CAS:64475-85-0
RTECS #:PY8240000
OSHA PEL:500 PPM 2950 MG/CU.M
ACGIH TLV:100 PPM 525 MG/CU.M.
Ingred Name:VOC. ORGANIC CMPD 4.0 LB/GAL LESS WATER & NPRS* 480 G/L
LESS WATER VOC. 10.1 LB/GAL SOLIDS 1212 G/L SOLIDS CALCULATE
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ASPIRATION OF MATERIAL INTO THE LUNGS
CAN CAUSE CHEMICAL PNEUMONITIS WHICH CAN BE FATAL. REPEATED EXPSR
TO CRYSTALLINE SILICA MAY CAUSE PNEUMOCONIOSIS A DISABLING LUNG
DISEASE. PROLONGED/REPEATED OVR EXPSR MAY CAUSE PERMANENT BRAIN &
NERVSSYS DAMAGE. INTENTIONAL MISUSE CAN BE HARMFUL OR FATAL.
Explanation of Carcinogenicity:AT TLV THE TI02 MANUFACTURER CONCLUDES
THAT THERE IS NO SIGNIFICIANT HAZARD FOR MAN.
Effects of Overexposure:INGST: GASTRONINTESTINAL
IRRITATION,NAUSEA,VOMITING,& DIARRHEA. INHL:
ANESTHETIC,IRRITATION TO NOSE/THROAT, HEADACHES, DIZZINESS, NAUSEA,
& CONFUSION.; SKIN: MAY CAUSE DEFATTING AND I RRITATIONEYE:
IRRITATION
Medical Cond Aggravated by Exposure:REPEATED EXPOSURE MAY CAUSE
PNEUMOCONIOSIS, A PROGRESSIVELY DISABLING LUNG DISEASE.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH W/LG AMNTS OF WTR, LIFTING EYELIDS, FOR 15
MINS,GET MEDICAL ATTENTIONSKIN: WASH AFFECTED AREA W/SOAP & WTR,
REMOVE CONTAM. CLOTHING.GET MED. ATTN. INHAL: REMOVE TO FRESH AIR
IMMEDIATELY,G IVE ARTIFICIAL RESP. IF NECESSARY, KEEPWARM & QUIET,
GET MEDICAL ATTENTION.
INGST: DO NOT INDUCE VOMITING. GET MEDICAL ATTENTION IMMEDIATELY
===================== Fire Fighting Measures =====================
Flash Point:102F/38.89C
Extinguishing Media:USE NFPA CLASS B FIRE EXTINGUISHERS,CARBON
DIOXIDE,DRY CHEMICAL,ALCOHOL FOAM. POLYMER FOAM IS PREFERRED FOR
LG. FIRES
Fire Fighting Procedures:WEAR SELF CONTAINED BREATHING APPARATUS. WATER
MAY BE INEFFECTIVE,MAY BE USED TOCOOL EXPOSED CONTAINERS. IF WATER
IS USED, FOG NOZZLES ARE PREFERRABLE.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE
FROM HEAT, ELECTRICAL EQUIPMENT,SPARKS &FLAME. CLOSED CONTAINERS
MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES. DIKE/CONTAIN
SPILLW/INERT MATL. PLACE ABSORBENT DIKING MATL IN COVERED METAL
CONTNR FOR DISPOSAL. USE ONLY NON SPARKNGTOOLS. PREVENT CONTAM. OF
SEWERS, GROUNDWATER, AND STREAMS W/SPILLED MATL OR USED ABSORBENT.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 95F. CLOSE CONTNR
AFTER EACH USE. EMPTY CONTNRS MUST NOT BE WASHED/REUSED FOR
NEVER USE PRESSURE TO EMPTY.
Other Precautions:DO NOT TAKE INTERNALLY. CONTAINERS SHOULD BE
GROUNDED/BONDED TO RECEIVING CONTNRDO NOT WELD,BRAZE OR CUT ON
EMPTY CONTAINERS. DRUM IS NOT A PRESSURE VESSEL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESTRICTED AREAS US NIOSH APPROVED CHEMICAL
CARTRIDGE RESPIRATOR. SPRAYING USE AMECHANICAL FILTER RESPIRATOR.
CONFINED AREAS USE A NIOSH APPROVED AIR SUPPLIED RESPIRATOR.
Ventilation:LOCAL EXHAUST VENTILATION OR GENERAL DILUTION
Other Protective Equipment:NONE
Work Hygienic Practices:NONE
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:280-388F
Vapor Density:> AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:60
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS OR ALKALINE MATERIALS
Stability Condition to Avoid:HEAT AND SOURCES OF IGNITION
Hazardous Decomposition Products:BURNING, INCLUDING WHEN HEATED BY
WELDING OR CUTTING, WILL PRODUCE SMOKE, CARBON MONOXIDE AND CARBON
DIOXIDE.
Conditions to Avoid Polymerization:HEAT SPARKS AND FLAME
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE W/FEDERAL,STATE,& LOCAL
LAWSINCINERATE ONLY IN EPA PERMITTED FACILITY. DO NOT INCINERATE
CLSD CONTAINERS. CONTAMINATED ABSORBANTMAY BE DISPOSED IN A
HAZARDOUS WASTE LANDFILL.TRAN SFER LIQ TO COVERED METAL CONTAINERS
FOR DISPOSAL.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:K-7510, R-7503, R-7512, & 4-7512U, (SUPDAT)
CAGE:7K791
CAGE:7K791
============= Composition/Information on Ingredients =============
Ingred Name:(DELTA(SUP 2,2')-BIINDOLINE)-5,5'-DISULFONIC ACID,
3,3'-DIOXO-, DISODIUM SALT; (INDIGO CARMINE)
CAS:860-22-0
RTECS #:DU3000000
Fraction by Wt: <0.2%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:POTASSIUM ACID PHTHALATE
CAS:877-24-7
Fraction by Wt: 1.0%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:DIETHYLENE GLYCOL
CAS:111-46-6
RTECS #:ID5950000
Fraction by Wt: 5.0%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: <95.0%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:NON-HAZARDOUS INGREDIENTS
Fraction by Wt: 1.0%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE TOXICITY:IRRITATION. CHRONIC
TOXICITY:IRRITATION AND SENSITIZATION DERMATITIS.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:MAY CAUSE IRRITATION TO EYES, SKIN
AND MUCOUS MEMBRANES.
======================= First Aid Measures =======================
First Aid:EYE AND SKIN CONTACT:IMMEDIATELY FLUSH EYES AND SKIN WITH
WATER FOR AT LEAST 15 MINUTES. INGEST:SEEK MEDICAL ATTENTION.
INHAL:REMOVE INDIVIDUAL TO FRESH AIR.
===================== Fire Fighting Measures =====================
Extinguishing Media:DRY CHEMICAL, CARBON DIOXIDE, WATER SPRAY OR FOAM.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:TAKE UP WITH ABSORBENT MATERIAL. PLACE IN
SMALL CONTAINERS FOR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:PRODUCT SHOULD BE STORED IN DARK & AT
ROOM TEMP; HOWEVER, TEMPS UP TO 120F/EVEN BELOW FREEZING WILL NOT
NORMALLY AFFECT REAGENT PERFORMANCE.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:ANSI APPRVD EMERGENCY EYE WASH & DELUGE
SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
MFR TRADE NAME/PART NO:DISSOLVED OXYGEN CHEMETS AND VACU-VIALS.
================== Physical/Chemical Properties ==================
HCC:T6
Boiling Pt:B.P. Text:230F,110C
Melt/Freeze Pt:M.P/F.P Text:30.2F,-1C
Spec Gravity:1.01
pH:4
Evaporation Rate & Reference:NOT KNOWN
Solubility in Water:COMPLETE
Appearance and Odor:YELLOW LIQUID, NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL FEDERAL, STATE
AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:T-GRADE MARKER INK, DYE TYPE, GREEN
CAGE:38512
CAGE:38512
============= Composition/Information on Ingredients =============
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:TECHNICAL GRADE, OIL SOLUBLE DYES, AS DYE COLORANT
Ingred Name:GLYCEROL ESTER OF POLYMERIZED ROSIN
===================== Hazards Identification =====================
Effects of Overexposure:XYLENE MAY BE NARCOTIC IN HIGH CONC
======================= First Aid Measures =======================
First Aid:CONTAINS XYLENE. IF SWALLOWED, DO NOT INDUCE VOMIT. CALL MD
IMMED. INH: REMOVE TO FRESH AIR. CALL MD. EYE: FLUSH IMMED W/WATER
AT LEAST 15 MIN. CALL MD. SKIN: WASH THOROUGHLY AFTER HANDLING.
===================== Fire Fighting Measures =====================
Flash Point:83F CC
Lower Limits:1.0
Upper Limits:7.0
Extinguishing Media:CO*2
Fire Fighting Procedures:MFR SUGGESTS SAME AS PAINT
Unusual Fire/Explosion Hazard:COMBUSTIBLE. DO NOT USE NEAR FIRE OR
FLAME.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB IN CLOTH OR SAWDUST. CLEAN W/NAPHTHA.
WASH W/SOAP & WATER, MFR REC.
======================Handling and Storage ======================
Handling and Storage Precautions:DRY, INSIDE STORAGE. STORE BELOW 120F.
AVOID PROLONGED CNTCT W/SKIN OR BRTHNG VAPOR.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPRVD RESP PROT IF INK IS SPRAYED
Ventilation:LOCAL EXH & MECH VENT, YES
Supplemental Safety and Health
VAP PRESS, XYLENE 10MMHG @27C. VAP DNSTY GIVEN FOR XYLENE. MFR SUGGESTS
SEEING "DANGEROUS PROPERTIES OF INDUSTRIAL MATERIALS" BY N IRVING
SAX, FOR ADDTL INFO.
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:280-283F
Vapor Density:3.7
Spec Gravity:0.91
Solubility in Water:NEGLIGIBLE
Appearance and Odor:NAPHTHA ODOR
Percent Volatiles by Volume:85
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
LACQUER THINNER & ALCOHOL, OXIDIZING MATLS
Stability Condition to Avoid:STORAGE ABOVE 120F. AVOID OPEN FLAME.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IAW LOCAL, STATE, FED REG.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:TRI-LUX II ANTIFOULING, BLACK, Y493
CAGE:028S6
CAGE:028S6
============= Composition/Information on Ingredients =============
Ingred Name:ZINC OXIDE (ZNO); (ZINC OXIDE)
CAS:1314-13-2
RTECS #:ZH4810000
Minumum % Wt:10.
Maxumum % Wt:25.
Other REC Limits:N/K
OSHA PEL:15 MG/M3
OSHA STEL:N/K
ACGIH TLV:10 MG/M3
ACGIH STEL:N/K
Ingred Name:SOLVENT NAPHTHA (PETROLEUM), LIGHT AROMATIC; (AROMATIC
HYDROCARBONS)
CAS:64742-95-6
RTECS #:WF3400000
Minumum % Wt:10.
Maxumum % Wt:25.
Other REC Limits:N/K
OSHA PEL:100 PPM
OSHA STEL:N/K
ACGIH TLV:N/K
ACGIH STEL:N/K
Ingred Name:TRIMETHYLBENZENE; (TRIMETHYL BENZENE)
CAS:25551-13-7
RTECS #:DC3220000
Minumum % Wt:10.
Maxumum % Wt:25.
Other REC Limits:N/K
OSHA PEL:25 PPM
OSHA STEL:N/K
ACGIH TLV:123 MG/M3;25 PPM
ACGIH STEL:N/K
Ingred Name:XYLENE
CAS:1330-20-7
RTECS #:ZE2100000
Minumum % Wt:1.
Maxumum % Wt:10.
Other REC Limits:N/K
OSHA PEL:100 PPM
OSHA STEL:150 PPM
ACGIH TLV:434 MG/M3;100 PPM
ACGIH STEL:651 MG/M3;150 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ETHYLBENZENE
CAS:100-41-4
RTECS #:DA0700000
Minumum % Wt:1.
Maxumum % Wt:10.
Other REC Limits:N/K
OSHA PEL:435 MG/M3;100 PPM
OSHA STEL:125 PPM
ACGIH TLV:434 MG/M3;100 PPM
ACGIH STEL:543 MG/M3;125 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Minumum % Wt:1.
Maxumum % Wt:10.
Other REC Limits:N/K
OSHA PEL:3.5 MG/M3
OSHA STEL:N/K
ACGIH TLV:3.5 MG/M3
ACGIH STEL:N/K
Ingred Name:ETHANOL
CAS:64-17-5
RTECS #:KQ6300000
Minumum % Wt:0.
Maxumum % Wt:1.
Other REC Limits:N/K
OSHA PEL:1900 MG/M3;1000 PPM
OSHA STEL:N/K
ACGIH TLV:1880 MG/M3;1000 PPM
ACGIH STEL:N/K
Ingred Name:CADMIUM
CAS:7440-43-9
RTECS #:EU9800000
Minumum % Wt:0.
Maxumum % Wt:1.
Other REC Limits:N/K
OSHA PEL:see 1910.1027
OSHA STEL:N/K
ACGIH TLV:0.01 MG/M3
ACGIH STEL:N/K
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:METHANOL
CAS:67-56-1
RTECS #:PC1400000
Minumum % Wt:0.
Maxumum % Wt:1.
Other REC Limits:N/K
OSHA PEL:260 MG/M3;200 PPM
OSHA STEL:250 PPM
ACGIH TLV:262 MG/M3;200 PPM
ACGIH STEL:328 MG/M3;250 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: INHALATION: CAUSES NOSE AND
THROAT IRRITATION. VAPOR HARMFUL. MAY AFFECT THE BRAIN OR NERVOUS
SYSTEM CAUSING DIZZINESS, HEADACHE OR NAUSEA. EYES: CAUSES EYE
IRRITATION. SKIN: CAN BE ABSORBED TH ROUGH THE SKIN. MAY CAUSE
ORGAN DAMAGE. CAUSES SKIN IRRITATION. INGESTION: MAY BE FATAL IF
SWALLOWED AND MAY CAUSE ORGAN DAMAGE. CHRONIC: CARBON BLACK HAS
BEEN DETERMINED BY IARC TO CAUSE CANCER IN LA BORATORY ANIMALS AND
CAN BE A POSSIBLE HUMAN CARCINOGEN.
Explanation of Carcinogenicity:CADMIUM: IARC MONOGRAPHS, VOLUME 58,
PAGE 119, 1998: GROUP 1. NTP 8TH ANNUAL REPORT ON CARCINOGENS,
1998: REASONABLY ANTICIPATED TO BE HUMAN CARCINOGEN. OSHA REGULATED
29 CFR 1910.1027. HUMAN: LUNG, P ROSTATE, RENAL SYSTEM EFFECTS.
CARBON BLACK: IARC MONOGRAPHS, VOLUME 65, PAGE 149, 1998: GROUP 2B.
ANIMAL: LUNG.
Effects of Overexposure:SEE HEALTH HAZARDS.
======================= First Aid Measures =======================
First Aid:GENERAL: IN ALL CASES OF DOUBT/WHEN SYMPTOMS PERSIST, SEEK
MEDICAL ATTN. NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS
PERSON. INHALATION: REMOVE TO FRESH AIR. IF DISCOMFORT IS
PRESENT/BREATHING IS A BSENT, GET MEDICAL ATTENTION IMMEDIATELY.
EYES: FLUSH IMMEDIATELY W/PLENTY OF WATER FOR AT LEAST 15 MINUTES,
UNTIL IRRIT SUBSIDES. IF IRRIT PERSISTS, GET MEDICAL ATTENTION.
SKIN: FLUSH W/LARGE AMOUNTOF WATER. USE SOAP IF AVAILABLE. REMOVE
SEVERELY-CONTAMINATED CLOTHING (INCLUDING SHOES) & WASH BEFORE
REUSE. IF IRRIT PERSISTS, GET MEDICAL ATTENTION. INGESTION: IF
SWALLOWED, DO NOT INDUCE VOMITING.KEEP AT REST. GET PROMPT
MEDICAL ATTN.
===================== Fire Fighting Measures =====================
Lower Limits:0.7% - 1.0%
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:ISOLATE FROM HEAT, SPARKS, ELECTRICAL
EQUIPMENT AND OPEN FLAME. CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. IN THE ABSENCE OF ELECTRICITY, A WATER
SPRAY (A FOG NOZZLE IS PREFERRED) MAY BE USED TO COOL CONTAINERS.
DECOMPOSITION AND COMBUSTION PRODUCTS MAY BE TOXIC.
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN SPILLED LIQUID WITH SAND OR EARTH. DO
NOT USE COMBUSTIBLE MATERIALS SUCH AS SAWDUST. ABSORB SPILL WITH AN
INERT MATERIAL (E.G., DRY SAND OR EARTH), THEN PLACE IN A CHEMICAL
WASTE CONTAINER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED. LOOSEN CLOSURE
CAUTIOUSLY BEFORE OPENING. STORE IN A COOL, WELL-VENTILATED PLACE,
AWAY FROM INCOMPATIBLE MATERIALS. (SEE STABILITY AND REACTIVITY
SECTION.) KEEP AWAY FROM HEAT, SPARKS AND FLAMES. PROTECT MATERIAL
FROM DIRECT SUNLIGHT.
Other Precautions:GROUND AND BOND CONTAINERS WHEN TRANSFERRING
MATERIALS. EMPTY CONTAINERS MAY RETAIN HAZARDOUS PROPERTIES. FOLLOW
ALL MSDS/LABEL WARNINGS, EVEN AFTER THE CONTAINER IS EMPTIED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE A RESPIRATOR APPROVED BY NIOSH AND IN
ACCORDANCE WITH 29 CFR 1910.134 TO REMOVE PARTICULATES (AND VAPORS
IF THERE IS OVEREXPOSURE TO VAPORS GENERATED DURING THE PROCESSING
OF THIS PRODUCT).
Ventilation:PROVIDE SUFFICIENT VENT, IN VOL & PATTERN, TO: A) KEEP TLV
OF HAZ INGS BELOW LIMS SPECIFIED; B) REMOVE VOLATILES PRDCED DURING
CURE & DECOMP PRODS (SUP DAT)
Other Protective Equipment:EYEWASH AND DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA . AS NEEDED, USE BODY PROTECTION TO AVOID CONTACT
WITH PRODUCT.
Supplemental Safety and Health
VENT: PRODUCED DURING WELDING/CUTTING ON SURFACES COATED W/THIS PROD.
================== Physical/Chemical Properties ==================
Vapor Density:HVR/AIR
Spec Gravity:1.349
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:LIQUID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products:MAY PRODUCE HAZARDOUS FUMES WHEN
HEATED TO DECOMPOSITION AS IN WELDING. FUMES MAY PRODUCE CARBON
DIOXIDE AND CARBON MONOXIDE.
=================== Toxicological Information===================
Toxicological Information:THERE IS NO DATA AVAILABLE ON THE PRODUCT
ITSELF. NOTICE: REPORTS HAVE ASSOCIATED REPEATED AND PROLONGED
OCCUPATIONAL OVEREXPOSURE TO SOLVENTS WITH PERMANENT BRAIN AND
NERVOUS SYSTEM DAMAGE. INTENTION AL MISUSE BY DELIBERATELY
CONCENTRATING AND INHALING THE CONTENTS MAY BE HARMFUL OR FATAL.
===================== Ecological Information =====================
Ecological:THERE IS NO DATA AVAILABLE ON THE PRODUCT ITSELF.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. DO NOT INCINERATE UNOPENED CONTAINERS.
=================== MSDS Transport Information ===================
Transport Information:DOT (DEPARTMENT OF TRANSPORTATION): PROPER
SHIPPING NAME: PAINT.
===================== Regulatory Information =====================
SARA Title III Information:SARA TITLE III (SUPERFUND AMENDMENTS AND
REAUTHORIZATION ACT): NONE KNOWN UNLESS CHEMICALS ARE SPECIFIED
BELOW (NONE LISTED). SECTION 313 REPORTABLE INGREDIENTS: NO
REPORTABLE INGREDIENTS.
Federal Regulatory Information:TSCA (TOXIC SUBSTANCE CONTROL ACT):
COMPONENTS OF THIS PRODUCT ARE LISTED ON THE TSCA INVENTORY. CERCLA
(COMPREHENSIVE RESPONSE COMPENSATION, AND LIABILITY ACT):
MANUFACTURER RECOMMENDS YOU CONTACT LO CAL AUTHORITIES TO DETERMINE
IF THERE MAY BE OTHER LOCAL REPORTING REQUIREMENTS.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:BARE WIRE 347
CAGE:27911
CAGE:27911
============= Composition/Information on Ingredients =============
Ingred Name:IRON
CAS:7439-89-6
RTECS #:NO4565500
Fraction by Wt: BALENCE
Other REC Limits:NONE
OSHA PEL:10MG/M3(FE203)
ACGIH TLV:5MG/M3(FE203)
Ingred Name:CHROMIUM (SARA III)
CAS:7440-47-3
RTECS #:GB4200000
Fraction by Wt: 19-21.5%
Other REC Limits:NONE
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3; 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:NICKEL (SARA III)
CAS:7440-02-0
RTECS #:QR5950000
Fraction by Wt: 9-11%
Other REC Limits:NONE
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3; 9192
Ingred Name:MANGANESE (SARA III)
CAS:7439-96-5
RTECS #:OO9275000
Fraction by Wt: 1.0-2.5%
Other REC Limits:NONE
OSHA PEL:(C) 5 MG/M3 DUST
ACGIH TLV:5 MG/M3 DUST 9293
Ingred Name:SILICON
CAS:7440-21-3
RTECS #:VW0400000
Fraction by Wt: 0.3-1.0%
Other REC Limits:NONE
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:MOLYBDENUM
CAS:7439-98-7
RTECS #:QA4680000
Fraction by Wt: 0.75%
Other REC Limits:NONE
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3; 9293
Ingred Name:COPPER (SARA III)
CAS:7440-50-8
RTECS #:GL5325000
Fraction by Wt: 0.75%
Other REC Limits:NONE
OSHA PEL:0.1MG/M3 FUME/1 DUST
ACGIH TLV:0.2MG/M3 FUME; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:GRAPHITE, SYNTHETIC
CAS:7440-44-0
RTECS #:FF5250100
Fraction by Wt: 0.08%
Other REC Limits:NONE
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:2 MG/M3 TDUST; 9293
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:METALLIC TASTE,NAUSEA,TIGHTNESS
OF CHEST,FEVER,DIZZINESS,DRYNESS,IRRITATION OF EYES,NOSE,THROAT.
CHRONIC: EXCESSIVE LEVELS MAY CAUSE BRONCHIAL ASTHMA,LUNG
FIBROSIS,PNEUMOCONIOSIS. LONG TERM EXPO SURE TO IRON FUMES MAY
PRODUCE SIDEROSIS. ARC RAYS MAY INJURE EYE & BURN SKIN. ELECTRIC
SHOCK CAN KILL.
Explanation of Carcinogenicity:CHROMIUM, NICKEL AND SOME OF THEIR
COMPOUNDS ARE LISTED AS CARCINOGENS BY NTP & IARC. SEE INDIVIDUAL
REPORTS FOR DATA.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH IMPAIRED
PULMONAARY FUNCTIONS OR ILLNESS MAY HAVE SYMPTOMS EXACERBATED BY
FUME IRRITANTS,
======================= First Aid Measures =======================
First Aid:REMOVE FROM DUST AND FUME EXPOSURE. IF BREATHING HAS STOPPED,
PERFORM ARTIFICIAL RESPIRATION. SUMMON MEDICAL AID IMMEDIATELY.
===================== Fire Fighting Measures =====================
Extinguishing Media:SUPPLIER DID NOT ADDRESS THIS FIELD.
Fire Fighting Procedures:SUPPLIER DID NOT ADDRESS THIS FIELD.
Unusual Fire/Explosion Hazard:WELDING ARCS, OPEN FLAME AND SPARKS CAN
IGNITE COMBUSTIBLES. SEE ANSI/ASC Z49.1-1983 SECTION 6.
================== Accidental Release Measures ==================
Spill Release Procedures:"NOT APPLICABLE"
Neutralizing Agent:NO INFORMATION GIVEN ON MSDS BY SUPPLIER
======================Handling and Storage ======================
Handling and Storage Precautions:NO INFORMATION GIVEN ON MSDS BY
SUPPLIER
Other Precautions:READ AND UNDERSTAND THE MANUFACTURER'S INSTRUCTIONS
AND THE PRECAUTIONARY LABEL ON THE PRODUCT. SEE AMSI STANDARD Z49.1
AND 29CFR1910 FOR DETAILS ON MANY PRECAUTIONS. TRAIN EMPLOYEE TO
KEEP HIS HEAD O UT OF FUMES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE RESPIRABLE FUME RESPIRATOR OR AIR SUPPLIED
RESPIRATOR WHEBN WELDING IN CONFINED SPACES OR WHERE LOCAL EXHAUST
OT VENTILATION DOES NOT KEEP EXPOSURE BELOW TLV.
Ventilation:USE ENOUGH VENTILATION OR LOCAL EXHAUST TO MAINTAIN
EXPOSURE AT OPERATOR'S BREATHING ZONE AND THE GENERAL AREA BELOW
TLV
Other Protective Equipment:MAY ALSO INCLUDE ARM PROTECTOR, APRON, HAT,
SHOULDER PROTECTION. SEE SUPP DATA.
Work Hygienic Practices:WASH HANDS THOROUGHLY BEFORE EATING,SMOKEING,
USING SANITARY FACILITIES.
Supplemental Safety and Health
BEING EXPOSED TO THE RADIATION FROM THE ELECTRIC ARC.
================== Physical/Chemical Properties ==================
HCC:N1
Solubility in Water:INSOLUBLE
Appearance and Odor:WELDING ROD.NO ODOR. 0.125 INCH DIAMETER BY 36
INCHES LONG.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:WELDING & BRAZING FUMES CANNOT BE
CLASSIFIED SIMPLY. COMPOSITION AND QUANTITY DEPEND ON BASE METAL,
FILLER METAL AND USE
==================== Disposal Considerations ====================
Waste Disposal Methods:"NOT APPLICABLE" HMIS: DISPOSE I/A/W ALL
FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
Subsets and Splits
No community queries yet
The top public SQL queries from the community will appear here once available.