text
stringlengths 542
18.7k
| label
int64 0
1
| label_text
stringclasses 2
values |
|---|---|---|
===================== Product Identification =====================
Product ID:ACTIVATED CARBON
Preparer's Name:D.E. KUBELDIS
CAGE:86368
CAGE:86368
============= Composition/Information on Ingredients =============
Ingred Name:GRAPHITE, SYNTHETIC
CAS:7440-44-0
RTECS #:FF5250100
Fraction by Wt: 100%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:2 MG/M3 TDUST; 9394
===================== Hazards Identification =====================
LD50 LC50 Mixture:ACUTE ORAL LD50 (RAT) >10 G/KG
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION- THE ACUTE INHALATION LC50
(RAT) IS >64.4 MG/L (NOMINAL CONCENTRATION) FOR ACTIVATED CARBON.
SKIN- THE PRODUCT IS NOT A PRIMARY SKIN IRRITANT. EYES- THE
PHYSICAL NATURE OF THE PRODUCT MAY P RODUCE EYE IRRITATION.
CHRONIC: THE EFFECTS OF LONG-TERM, LOW-LEVEL EXPOSURES TO THIS
PRODUCT HAVE NOT BEEN DETERMINED.
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES- FLUSH WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES.
SKIN- WASH WITH SOAP AND WATER.
===================== Fire Fighting Measures =====================
Extinguishing Media:IF INVOLVED IN FIRE, FLOOD WITH PLENTY OF WATER.
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:CONTACT WITH STRONG OXIDIZERS SUCH AS
OZONE, LIQUID OXYGEN, CHLORINE, PERMANGANATE, ETC. MAY RESULT IN
FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP UNUSED CARBON AND DISCARD IN REFUSE
CONTAINER OR REPACKAGE.
======================Handling and Storage ======================
Handling and Storage Precautions:WET ACTIVATED CARBON REMOVES OXYGEN
FROM AIR CAUSING A SEVERE HAZARD TO WORKERS INSIDE CARBON VESSELS
AND ENCLOSED OR CONFINED SPACES.
Other Precautions:WASH THOROUGHLY AFTER HANDLING. EXERCISE CAUTION IN
THE STORAGE AND HANDLING OF ALL CHEMICAL SUBSTANCES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:A NIOSH-APPROVED PARTICULATE FILTER RESPIRATOR
IS RECOMMENDED IF EXCESSIVE DUST IS GENERATED.
Ventilation:LOCAL EXHAUST AND MECHANICAL VENTILATION RECOMMENDED.
Other Protective Equipment:NOT REQUIRED.
Work Hygienic Practices:WASH HANDS THOROUGHLY AFTER HANDLING THIS
MATERIAL.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:2.3 G/CC
Solubility in Water:INSOLUBLE
Appearance and Odor:BLACK PARTICULATE SOLID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS SUCH AS OZONE, LIQUID OXYGEN, CHLORINE, PERMANGANATE,
ETC.
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:CARBON MONOXIDE MAY BE GENERATED IN
THE EVENT OF FIRE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF UNUSED CARBON IN REFUSE CONTAINER.
DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:5750 BLACK DEVELOPER
Resp. Party Other MSDS Num.:B-0293
CAGE:2M912
CAGE:2M912
============= Composition/Information on Ingredients =============
Ingred Name:CERAMIC MATERIALS AND WARES, CHEMICALS; (CU-ZN FERRITE
POWDER)
CAS:66402-68-4
Minumum % Wt:85.
Maxumum % Wt:95.
Ingred Name:POLYESTER
CAS:128781-91-9
Minumum % Wt:4.
Maxumum % Wt:5.
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Minumum % Wt:.1
Maxumum % Wt:.25
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT): >5000 MG/KG.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: NON-IRRITANT FOR SKIN.
NON-SENSITIZER FOR SKIN. NON-IRRITATING TO THE EYES. MUTAGENIC
EFFECTS: NO MUTAGENICITY DETECTED IN AMES ASSAYS.
Explanation of Carcinogenicity:CARBON BLACK: IARC MONOGRAPHS ON THE
EVALATION OF CARCINOGENIC RISK OF CHEMICALS TO MAN, VOLUME 65, PAGE
149, 1996: GROUP 2B.
Effects of Overexposure:MINIMAL RESPIRATORY TRACT IRRITATION MAY OCCUR
AS WITH EXPOSURE TO LARGE AMOUNTS OF ANY NON-TOXIC DUST.
Medical Cond Aggravated by Exposure:NONE WHEN USED AS DESCRIBED BY
PRODUCT LITERATURE.
======================= First Aid Measures =======================
First Aid:EYE CONTACT: RINSE WITH WATER FOR AT LEAST 15 MINUTES. SKIN
CONTACT: WASH WITH SOAP AND WATER. INHALATION: REMOVE FROM
EXPOSURE. INGESTION: DILUTE STOMACH CONTENTS WITH SEVERAL GLASSES
OF MILK OR WATE R.
===================== Fire Fighting Measures =====================
Flash Point:NA
Autoignition Temp:Autoignition Temp Text:NA
Lower Limits:NA
Upper Limits:NA
Extinguishing Media:USE WATER SPRAY, FOG OR FOAM. AVOID INHALATION OF
SMOKE.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE. PRODUCTS OF COMBUSTION: MAY BE
TOXIC. SPECIAL REMARKS ON FIRE HAZARDS: NONE. SPECIAL REMARKS ON
EXPLOSION HAZARDS: NONE. NATIONAL FIRE PROTECTION ASSOCIATION (USA)
704: FIRE HAZARD: 1 REACTIVITY : 0. HEALTH: 0. HMIS (USA): HEALTH
HAZARD: 0. FIRE HAZARD 1. REACTIVITY: 0. PERSONAL PROTECTION: A.
================== Accidental Release Measures ==================
Spill Release Procedures:SPILL OR LEAKAGE: IF SPILLED, SWEEP UP OR
VACUUM.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE. NIOSH APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONERN .
Ventilation:NONE.
Other Protective Equipment:EYE WASH & DELUGE SHWR MTG ANSI DESIGN
CRITERIA . FOR USE OTHER THAN NORM CUSTOMER OPER PROC (SUCH AS BULK
MORE INFO, CNTCT XEROX.
Supplemental Safety and Health
PART NO: OEM: 5R60336, 118-9782-00; WH: 5R319, 5R587, 5R597; XCL:
5R563; XL: 5R90210; XLA: 5R323. ENG DRWG NO 600E67400. PHYSICAL
CHARACT: SOFTENING RANGE, VOC: NA. OTHER INFO:TOX EFTS IN HUMANS:
NOHUMAN DATA AVAIL.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:NA
Melt/Freeze Pt:M.P/F.P Text:NA
Vapor Pres:NA
Vapor Density:NA
pH:NA
Viscosity:NA
Evaporation Rate & Reference:NA
Solubility in Water:NOT DETERMINED.
Appearance and Odor:BLACK SOLID (GRANULES); SLIGHT ODOR.
Percent Volatiles by Volume:NA
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Hazardous Decomposition Products:NOT AVAILABLE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
=================== Toxicological Information===================
Toxicological Information:ACUTE: EYE IRRIT: NON-IRRIT TO EYES. SKIN
SENSITIZER: NON-SENSITIZER FOR SKIN. SKIN IRRIT: NON-IRRIT FOR
SKIN. HUMAN SKIN PATCH: NON-IRRIT, NON-SENSITIZING. DERMAL (LD50):
>5000 MG/KG (RABBIT). INHAL ((LC50): >5 MG/L (RATS) 4 HR. INHAL
(LC50): >20 MG/L (CALCULATED) 1HR. CHRONIC: ADDITIONAL INFO:
RESULTS OBTAINED FROM XEROX SPONSORED CHRONIC TONER INHAL STUDY,
DEMONSTRATED NO LUNG CHANGE IN RATS FO R LOWEST (1 MG/M3) EXPOS
LEVEL (I.E. LEVEL MOST RELEVANT TO POTENTIAL HUMAN EXPOS). A VERY
SLIGHT DEGREE OF FIBROSIS WAS NOTED IN 25% OF ANIMALS AT MIDDLE (4
MG/M3) EXPOS LEVEL, WHILE A SLIGHT DEGREE OF FIBROSIS WAS NOTED
(OTHER INFO)
===================== Ecological Information =====================
Ecological:ECOTOXICITY: AQUATIC (LC50): >1000 MG/L (RAINBOW TROUT). BOD
AND COD, PRODUCTS OF BIODEGRADATION, BIOACCUMULATION, TOXICITY OF
THE PRODUCTS OF BIODEGRADATION: NOT AVAILABLE. SPECIAL REMARKS ON
THE PRO DUCTS OF BIODEGRADATION: NO ADDITIONAL REMARKS.
==================== Disposal Considerations ====================
Waste Disposal Methods:THIS MATERIAL IS NOT A HAZARDOUS WASTE ACCORDING
TO FEDERAL REGULATION 40 CFR 261 WHEN DISPOSED. CONSULT WITH THE
APPROPRIATE FEDERAL, STATE AND LOCAL WASTE DISPOSAL AUTHORITIES FOR
ADDITIONAL INFORMA TION. WASTE STREAM: NOT AVAILABLE.
=================== MSDS Transport Information ===================
Transport Information:USA/DOT PROPER SHIPPING NAME: NOT APPLICABLE.
HAZARD CLASS: NOT REGULATED. DOT IDENTIFICATION NUMBER: NOT
APPLICABLE. PACKING GROUP: NOT APPLICABLE. CANADA/TDG PIN NUMBER:
NOT APPLICABLE. TDG CLASSIFI CATION: NOT CONTROLLED UNDER TDG
(CANADA). IMO/IMDG CLASSIFICATION: NOT CONTROLLED UNDER IMDG. IATA
CLASSIFICATION: NOT CONTROLLED UNDER IATA.
===================== Regulatory Information =====================
SARA Title III Information:SARA 313 TOXIC CHEMICAL NOTIFICATION AND
RELEASE REPORTING; CU-ZN FERRITE PRODER.
Federal Regulatory Information:US FEDERAL AND STATE REGULATIONS: TSCA
INVENTORY: ALL INGREDIENTS ARE LISTED. WHMIS (CANADA): NOT
CONTROLLED UNDER WHMIS (CANADA). CANADIAN FEDERAL AND PROVINCIAL
REGULATIONS: NO PRODUCTS WERE FOUND.
State Regulatory Information:FINAL PRODUCT EXPOSURE LIMITS PEL/TLV/XEL:
ACHIG (TLV):10.0 (MG/M3) TOTAL. OSHA (PEL): 15.0 (MG/M3) TOTAL.
OSHA (PEL): 5.0 (MG/M3) RESPIRAGLE. XEROX (XEL): 2.5 (MG/M3) TOTAL.
XEROX (XEL): 0.4 (MG/M3) RESPIRALE. XEL: XEROX EXPOS LIMIT.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:209A111 MAPLE, PIGMENTED OIL WOOD STAIN
CAGE:ACEHA
CAGE:ACEHA
============= Composition/Information on Ingredients =============
Ingred Name:KEROSENE (PETROLEUM), HYDROTREATED; (MINERAL SPIRITS). VP:
2.
CAS:64742-47-8
RTECS #:OA5504000
Fraction by Wt: 72%
OSHA PEL:500 PPM (MFR)
ACGIH TLV:100 PPM (MFR)
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL: ANESTHETIC. IRRITATION
OF RESPIRATORY TRACT OR NERVOUS SYSTEM DEPRESSION. HEADACHE,
DIZZINESS, NAUSEA, CONFUSION, UNCONSCIOUSNESS OR COMA. SKIN/EYE
CONTACT: PRIMARY IRRITATION. CHRONIC: REPORTS HAVE ASSOC
REPEATED/PROLONGED OCCUPATIONAL OVEREXPOSURE TO SOLVENTS
W/PERMANENT BRAIN & NERVOUS SYSTEM DAMAGE.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE FROM EXPOSURE, RESTORE BREATHING, KEEP WARM &
QUIET, NOTIFY MD. EYES: FLUSH IMMED W/RUNNING WATER FOR A MINIMUM
OF 15 MINUTES. SKIN: WASH W/SOAP & WATER AND APPLY SKIN CREAM.
NOTIFY MD I N ALL CASES. INGEST: CALL MD IMMEDIATELY .
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:105F,41C
Lower Limits:0.9%
Extinguishing Media:FOAM, "ALCOHOL" FOAM, CO2, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. DURING EMER CNDTNS OVEREXP TO DECOMP PRODS MAY CAUSE HLTH HAZ.
SYMP MAY NOT BE IMMED APPARENT. (SUPP DATA)
Unusual Fire/Explosion Hazard:KEEP CONTRS TIGHTLY CLOSED. ISOLATE FROM
HEAT, ELEC EQUIP, SPARKS, AND OPEN FLAME. HEAT MAY CAUSE PRESSURE
BUILD-UP IN CLOSED CONTRS, WATER MAY BE USED TO COOL.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DOL STORAGE CATEGORY 2. CONTENTS ARE
COMBUSTIBLE. KEEP AWAY FROM HEAT & OPEN FLAME. USE ONLY W/ADEQ
VENTILATION. KEEP CONTR CLOSED WHEN NOT IN USE.
Other Precautions:AVOID BRTHG VAPOR/SPRAY MIST. AVOID CONTACT W/SKIN &
EYES. WASH HANDS AFTER USING. DO NOT TRANSFER CONTENTS TO OTHER
CONTRS FOR STORAGE. DO NOT TAKE INTERNALLY. KEEP OUT OF REACH OF
CHILDREN. CONSULT NFPA CODE. USE APPRVD BOND/GROUND PROC.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF ENGINEERING AND ADMINISTRATIVE CONTROLS OF
AIR CONTAMINANTS ARE NOT POSSIBLE, USE RESPIRATORY DEVICES APPROVED
BY NIOSH/ MSHA FOR PROTECTION AGAINST SPRAY MIST AND VAPORS.
Ventilation:LOCAL EXHAUST PREFERABLE. MECHANICAL (GENERAL) EXHAUST
ACCEPTABLE. SPECIAL VENTILATION REQUIRED TO KEEP BELOW TLV/LEL.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:REMOVE AND WASH CONTAMINATED CLOTHING, DISCARD
CONTAMINATED SHOES. WASH HANDS AFTER USING.
Supplemental Safety and Health
FIRE FIGHT PROC: OBTAIN MEDICAL ATTENTION. WATER SPRAY MAY BE
INEFFECTIVE. WATER MAY BE USED TO COOL CLOSED CONTAINERS TO PREVENT
PRESSURE BUILD-UP AND POSSIBLE AUTO IGNITION OR EXPLOSION WHEN
EXPOSED TO EXTREME HEAT.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:308F,153C
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Spec Gravity:0.876
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:72
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE REASONABLY FORESEEABLE.
Stability Condition to Avoid:HIGH TEMPERATURES, OPEN FLAME.
Hazardous Decomposition Products:BY FIRE: CO2 AND CO.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE IN APPROVED FACILITY. DO NOT
INCINERATE CLOSED CONTAINERS. DISPOSE OF IN ACCORDANCE WITH
FEDERAL, STATE, AND LOCAL REGULATIONS REGARDING POLLUTION.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:LUCITE ACRYLIC LACQUER,YELLOW, 8850-LH
CAGE:DO229
CAGE:18873
CAGE:DO229
============= Composition/Information on Ingredients =============
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 6.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/150STEL;9394
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ALIPHATIC ALCOHOL
Fraction by Wt: 7.0%
ACGIH TLV:400PPM(PER MFR)
Ingred Name:ALIPHATIC ESTER
Fraction by Wt: 7.0%
ACGIH TLV:100PPM(PER MFR)
Ingred Name:ALIPHATIC KETONE
Fraction by Wt: 13.0%
ACGIH TLV:100PPM(PER MFR)
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 23.0%
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Effects of Overexposure:CAUSES HEADACHE,NAUSEA,IMPAIRMENT OF REACTION
TIME AND COORDINATION.
======================= First Aid Measures =======================
First Aid:INHALATION:MOVE TO FRESH AIR TO IMPROVE BREATHING;SKIN:WASH
WITH SOAP & WATER.REMOVE CONTAMINATED CLOTHING;EYES:FLUSH WITH
WATER FOR AT LEAST 15 MIN.CALL A PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:20-73F (CC)
Lower Limits:1.10
Upper Limits:12.8
Extinguishing Media:CO*2, FOAM, DRY CHEM.
Fire Fighting Procedures:COOL CLOSED CONTNRS W/H*2O USING FOG NOZZLES.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE UNPROTECTED PERSONS. ELIM IGNITION
SOURCES. STOP LEAK. H*2O SPRAY COOL CONT/DIVERT SPILL FROM
FIRE/HEAT. PROVIDE VENTILATION. ABSORB W COMMERCIAL
ABSORBENT,SHOVEL INTO METAL DRUMS:LG SPILL:DI KE W COMMERCIAL
ABSORBENT,PUMP INTO COVERED DRUMS.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT,SPARKS & OPEN
FLAMES.CLOSE CONTAINERS AFTER EACH USE.DO NOT STORE ABOVE 120F
Other Precautions:WASH THOROUGHLY AFTER HANDLING AND BEFORE EATING OR
SMOKING;OBSERVE LABEL PRECAUTIONS;CONTAINERS SHOULD BE GROUNDED
WHEN POURING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA RESP TC-23C IF AIR CONTMNANTS
CONTROL IS NOT FEASIBLE
Ventilation:LOCAL & MECH PROVIDE SUFFICIENT VENT TO KEEP BELOW TLV
LEVEL
Other Protective Equipment:USE APPROPRIATE INDUSTRIAL HYGIENE
PRACTICES.
Supplemental Safety and Health
NIOSH 6:1000768EE,ETHER ESTER,3%,100PPM;NIOSH 7:OF7525000,LEAD,CAS
#7439-92-1,7.5%,0.05MG/CUM;NIOSH 8:GB6475000,CHROMIUM
TRIOXIDE,CAS#1308-38-9,2.36%,0.10 MG(CR)/CUM;NIOSH 9:SEE ADDL DATA-
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:129-437F
Vapor Pres:36
Vapor Density:3.10
Spec Gravity:1.084
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:MODERATE
Appearance and Odor:LIQUID PAINT W/CHARACTERISTIC ODOR.
Percent Volatiles by Volume:72.9
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS, CORROSIVES
Stability Condition to Avoid:HEAT, IGNITION SOURCES
Hazardous Decomposition Products:CO,CO*2,SMOKE,OXIDES OF
LEAD,CHROMIUM,ANTIMONY
==================== Disposal Considerations ====================
Waste Disposal Methods:KEEP IN COVERED DRUMS,PENDING DISPOSAL. HANDLE &
DISPOSE IN FULL COMPLIANCE WITH ALL APPLICABLE
INTERNATIONAL,FEDERAL,STATE, & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:COATING, POLYURETHANE, COMP B ID 754201
Kit Part:Y
Preparer's Name:W A ELLISON
CAGE:61196
CAGE:61196
============= Composition/Information on Ingredients =============
Ingred Name:N-BUTYL ACETATE (SOLVENT) (SARA III) (VAPOR PRESSURE 10 MM
HG @ 20C) (LFL 1.7; UFL 7.6)
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: 25%
Other REC Limits:NONE RECOMME
OSHA PEL:150 PPM;STEL 200 PPM
ACGIH TLV:150 PPM;STEL 200 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:1,6-HEXANE METHYLENE DIISOCYANATE (RESIN)
CAS:822-06-0
RTECS #:MO1740000
Fraction by Wt: <5%
Other REC Limits:MFR: 0.0050
ACGIH TLV:0.0050 PPM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:POLYMERIC HEXAMETHYLENE DIISOCYANATE (RESIN)
CAS:28182-81-2
RTECS #:NQ9170000
Fraction by Wt: 75%
Other REC Limits:MFR 1 MG/M3
Ingred Name:VOC: 2.20 LB/GAL LESS WATER & NEGLIGIBLY PHOTOCHEMICALLY
REACTIVE MATERIALS; 264 G/L LESS WATER; CALCULATED
RTECS #:9999999VO
Other REC Limits:NONE RECOMME
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:ACUTE; INGEST: FATAL, GI IRRIT,
NAUSEA, VOMITING. ASPIRATION INTO LUNG MAY CAUSE CHEM PNEUMONITIS
(CAN BE FATAL). INHAL: VAPOR/SPRAY HARMFUL. LUNG DAMAGE, LUNG IRRIT
& ALLERGIC RESP REACTION (MAY BE P ERMANENT). SENSITIZATION, RESP
IRRIT. EYE: SEVERE IRRIT. SKIN: PRIMARY SKIN IRRIT, SENSITIZATION
(ALLERGIC REACTION).
Effects of Overexposure:CHRONIC; REPEATED EXPOSURE TO DIISOCYANATES MAY
RESULT IN RESPIRATORY SENSITIZATION IN SOME INDIVIDUALS.
RESPIRATORY SENSITIVITY RESULTS IN ASTHMA LIKE SYMPTOMS ON
SUBSEQUENT EXPOSURE AT CONCENTRATION S BELOW TLV. REPORTS ASSOCIATE
PROLONGED/REPEATED OVEREXPOSURE WITH PERMANENT BRAIN & NERVOUS
SYSTEM DAMAGE.
Medical Cond Aggravated by Exposure:THIS PRODUCT SHOULD NOT BE USED BY
PERSONS WHO HAVE HAD CHRONIC (LONG TERM) BREATHING PROBLEMS OR
REACTIONS TO ISOCYANATES.
======================= First Aid Measures =======================
First Aid:INGEST: DONT INDUCE VOMITING. CALL POISON CTR/EMERG ROOM/DR
IMMED. INHAL:REMOVE TO FRESH AIR IMMED. IF BREATHING STOPPED, GIVE
ARTIF RESPRTN. KEEP WARM & QUIET. GET MED AID IMMED. EYE: FLUSH
W/WATER 1 5 MIN, LIFTING EYELIDS. GET MED AID. SKIN: REMOVE CONTAM
CLOTHES. WASH AFFECTED AREA W/SOAP & WATER. GET MED AID IF IRRIT
PERSISTS. NOTE TO DR:DIRECT TREATMENT AT CLINICAL CONDITION &
SYMPTOM CONTROL.
===================== Fire Fighting Measures =====================
Flash Point:72.0F,22.2C
Autoignition Temp:Autoignition Temp Text:572 F
Lower Limits:1.7
Upper Limits:7.6
Extinguishing Media:NFPA CLASS B EXTINGUISHERS (CO2, DRY CHEMICAL,
ALCOHOL FOAM) FOR FLAMMABLE LIQ. POLYMER FOAM PREFERRED FOR LARGE
FIRES.
Fire Fighting Procedures:WATER MAY BE INEFFECTIVE, USE TO COOL EXPOSED
CONTAINERS (FOG NOZZLES PREFERRED) TO PREVENT PRESSURE BUILDUP,
AUTOIGNITION OR EXPLOSION WHEN EXPOSED TO HEAT.
Unusual Fire/Explosion Hazard:DURING EMERG CONDITIONS, OVEREXPOSURE TO
DECOMPOSITION PRODUCTS MAY BE HEALTH HAZARD. SYMPTOMS MAY NOT BE
IMMEDIATELY APPARENT. OBTAIN MEDICAL AID. FLAMMABLE.
================== Accidental Release Measures ==================
Spill Release Procedures:USE TC19C AIR SUPPLD BREATH APPARATUS.WEAR
RSPRTR,EYE,HAND,BODY PROTECT.KEEP SPECTATOR AWAY.ELIMINATE IGNIT
SOURCE.DIKE W/INERT MAT'L(SAND,EARTH,ETC).TRANSFR LIQ/USED ABSORB
TO CVRD METAL CNTNR.USE NO N-SPARK TOOL.PREVENT
SEWER,STREAM,GROUNDWTR CONTAM
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 115 F. STORE LARGE
QUANTITIES IN COMPLIANCE WITH OSHA 29 CFR 1910.106. DO NOT TAKE
INTERNALLY. DO NOT BREATHE SANDING DUST.
Other Precautions:CLOSE CONTAINER AFTER EACH USE. DO NOT WASH & REUSE
EMPTY CONTAINERS FOR ANY PURPOSE. GROUND & BOND CONTAINERS TO
RECEIVING CONTAINER. DONT WELD, BRAZE, OR CUT ON EMPTY CNTNR. NEVER
USE PRESSURE TO EM PTY. DRUM IS NOT A PRESSURE VESSEL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR FITTED POSITIVE PRESSR AIR SUPPLD RSPRTR
(TC19C). UNAVAILABLE,USE VAPOR PARTIC (PAINT SPRAY) RSPRTR
EFFECTIVE FOR ISOCYANATE VAPOR. WEAR RSPRTR WHILE MIX,SPRAY,TILL
VAPOR GONE. FOLLOW DIRECTN.REF ER TO OSHA 29 CFR 1910.134 RESP
PROTECTN
Ventilation:LOCAL EXHAUST VENT TO KEEP BELOW TLV. REMOVE DECOMPOSITION
PRODUCT. SEE "INDUST VENT-MANUAL RECOMMENDED PRACTICES" ACGIH
Other Protective Equipment:AS REQUIRED TO PREVENT SKIN CONTACT.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. DO NOT GET IN
EYES, ON SKIN, OR CLOTHING.
Supplemental Safety and Health
URETHANE ACTIVATOR IS ONE PART OF TWO COMPONENT MIXTURE. INTENDED TO BE
MIXED W/BASE. CONTENTS OF PACKAGE MUST BE BLENDED W/OTHER
COMPONENTS BEFORE PRODUCT CAN BE USED. BEFORE OPENING PACKAGES, BE
SUR E YOU UNDERSTAND WARNING MESSAGES & LABELS OF ALL COMPONENTS,
MIX WILL HAVE HZDS OF ALL PARTS. FOLLOW ALL PRECAUTIONS.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:260F,127C
Melt/Freeze Pt:M.P/F.P Text:-50F,-46C
Decomp Temp:Decomp Text:1832F,1000C
Vapor Pres:10 @ 68F
Vapor Density:> AIR
Spec Gravity:1.1
pH:4-7
Evaporation Rate & Reference:SLOWER THAN DIETHYL ETHER
Solubility in Water:SLIGHT IN WATER
Appearance and Odor:LIQUID, SOLVENT ODOR
Percent Volatiles by Volume:30
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS OR ALKALINE MATERIALS. OXIDIZING MATERIALS.
Stability Condition to Avoid:AVOID EXCESSIVE HEAT (>115F) AND SOURCES
OF IGNITION.
Hazardous Decomposition Products:BURNING,INCLUDING WHEN HEATED BY
WELDING/CUTTING,WILL PRODUCE SMOKE,CARBON MONOXIDE & CARBON
DIOXIDE. OXIDES OF NITROGEN
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORD W/FED, STATE & LOCAL
LAWS/REGS. THIS PRODUCT, IF DISCARDED DIRECTLY, WOULD BE CLASSIFIED
A HAZARDOUS WASTE BASED ON ITS IGNITABILITY CHARACTERISTIC, I.E.
HAS A FLASH POINT OF 140F OR LESS. RCRA CLASSIFICATION WOULD BE
D001.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:S72DFK CHEM BLEND FIXER PART 2 (HARDENER)
CAGE:KO055
CAGE:KO055
CAGE:27912
============= Composition/Information on Ingredients =============
Ingred Name:ACETIC ACID (SARA III)
CAS:64-19-7
RTECS #:AF1225000
Fraction by Wt: 15-25%
Other REC Limits:NONE SPECIFIED
OSHA PEL:10 PPM
ACGIH TLV:10 PPM/15 STEL; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ALUMINUM SULFATE (SARA III)
CAS:10043-01-3
RTECS #:BD1700000
Fraction by Wt: 15-30%
Other REC Limits:NONE SPECIFIED
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PRODUCT MAY CAUSE BURNS TO EYE OR
SKIN, OR RESPIRATORY OR G/I TRACT IRRITATION. IT IS CONSIDERED A
MODERATE HAZARD FOR NORMAL INDUSTRIAL HANDLING.
Explanation of Carcinogenicity:THIS PRODUCT CONTAINS NO INGREDIENT
LISTED AS CARCINOGEN BY IARC,NTP, OR OSHA.
Effects of Overexposure:EYE:CAUSES SEVERE IRRITATION,BURNS SKIN:CAUSES
SEVERE IRRITATION,BURNS. INHALED:MAY CAUSE IRRITATION IF MIST IS
INHALED. INGESTED:MAY BE HARMFUL IF SWALLOWED. HMIS:MAY CAUSE G/I
IRRITATION,NAUSEA,VO MITING.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH W/WATER 15 MIN, HOLD LIDS OPEN. SKIN:WASH WITH
SOAP & WATER. REMOVE CONTAMINATED CLOTHING AND LAUNDER BEFORE
REUSE. INHALED:REMOVE TO FRESH AIR. RESTORE BREATHING IF
NECESSARY.INGESTED:D O NOT INDUCE VOMITING. GIVE 2 LARGE GLASSES
OF MILK OR WATER AND GET IMMEDIATE MEDICAL CARE. GIVE NOTHING BY
MOUTH IF UNCONSCIOUS. IF IRRITATION PERSISTS OR IS SEVERE,SEE A
DOCTOR.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Extinguishing Media:PRODUCT IS NON FLAMMABLE. EXTINGUISH FIRE WITH
MEDIA APPROPRIATE FOR SOURCE OF FIRE.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED
CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:RECOVER AS LIQUID OR ADSORB WITH
CLOTH,PAPER,OTHER INERT MATERIAL.
Neutralizing Agent:SODIUM BICARBONATE
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL (40-90 F), DRY, WELL
VENTILATED AREA.
Other Precautions:READ LABEL THEN FOLLOW INSTRUCTIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESPIRATOR WILL NOT NORMALLY BE NECESSARY. USE
NIOSH/MSHA APPROVED AIR SUPPLIED RESPIRATOR OR RESPIRATOR FOR
INORGANIC DUST/MIST IF EXPOSURE IS ABOVE THE TLV/PEL. SEE 29 CFR
1910.134 FOR REGULATIONS PERTAINING TO RESPIRATOR USE.
Ventilation:NORMAL ROOM VENTILATION SUPPLEMENTED WITH LOCAL EXHAUST
ESPECIALLY WHEN MIXING.
Other Protective Equipment:EYE WASH STATION & SAFETY SHOWER. USE APRON
AND FACE SHIELD WHEN MIXING LIQUIDS OR IF SPLASHING IS LIKELY.
Work Hygienic Practices:USE GOOD CHEMICAL HYGIENE PRACTICE. AVOID
UNNECESSARY CONTACT.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:>212F,>100C
Vapor Pres:18 MM
Vapor Density:0.6
Spec Gravity:1.21
pH:ACID
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR COLORLESS LIQUID, VINEGAR ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ALKALIS
Stability Condition to Avoid:NONE GIVEN BY MANUFACTURER (SUPPLIER).
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
SULFUR OXIDES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE I/A/W FEDERAL,STATE,LOCAL REGULATIONS.
MFR SUGGESTS FLUSH TO SEWER IF PERMITTED.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:HDX ALL PURPOSE GEAR LUBE SAE 80W/90
CAGE:DO762
CAGE:01326
CAGE:DO762
============= Composition/Information on Ingredients =============
Ingred Name:PETROLEUM HYDROCARBON LUBRICANT
===================== Hazards Identification =====================
Effects of Overexposure:SKIN: PRLNG EXPOS-DERMAT INHAL:
MIST/FUMES-ASPIRATION PNEUMONIA. INGEST: NAUS,LAXATIVE; EYE: IRRIT
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/ WARM WATER, IF LIQ IS HOT-TREAT FOR BURNS,SEE
MD. SKIN: WASH W/ SOAP & WATER. HOT LIQ MAY CAUSE SEVERE BURNS. FOR
BURNS: CHILL AREA,TREAT FOR SHOCK, SEE MD. INHAL: REMOVE TO FRESH
AIR I MMED. IF BREATH STOPS GIVE ARTF RESP SEE SUPP DATA
===================== Fire Fighting Measures =====================
Flash Point:425F; 218C (COC)
Extinguishing Media:FOAM, DRY CHEM, CO*2
Fire Fighting Procedures:DO NOT USE STREAM OF H*2O-CAUSES FROTHING &
SPREADS FIRE.
Unusual Fire/Explosion Hazard:CO AND SOOT CAN BE PRODUCED IN AN OXYGEN
DEFICIENT FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL SPILLS: PICK UP W/ ABSORBENTS. LARGE
SPILLS: USE PUMPS,BUCKETS,SHOVELS,OR OTHER APPLICABLE TOOLS. PUT
DRY SAND OR SPECIAL OIL ABSORBENT ON OILY AREAS TO HELP PREVENT
ACCIDENTS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AS A FLAMMABLE AND COMBUSTIBLE
LIQUID. DO NOT TRANSFER TO UNMARKED CONTAINER. RESP PROTECT: DO NOT
USE COMPRESSED O*2 IN HYDROCARBON ATMOSPHERES
Other Precautions:WASH THOROUGHLY AFTER HANDLING. CONSUMPTION OF FOOD &
BEVERAGES IS PROHIBITED IN AREAS WHERE HYDROCARBONS ARE PRESENT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:MFR RECOMNDS NIOSH/MSHA APPRVD RESPIRATOR FOR
PARTICULAR EXPOSURE.
Ventilation:SUFFICIENT VENT TO KEEP BELOW TLV.
Other Protective Equipment:PLASTIC OR RUBBERIZED PERSONAL PROTECTIVE
EQUIPMENT.
Supplemental Safety and Health
FIRST AID PROCEDURES: INGEST: DO NOT INDUCE VOMITING, CALL MD. BOILING
PT: >900F;482C (MIDPOINT). CONTAINER: 1 QT CAN
================== Physical/Chemical Properties ==================
HCC:V6
Boiling Pt:B.P. Text:SEE SUP DTA
Spec Gravity:0.896
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR, DARK RED MILD SULFUR ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:MFR RECOMMENDS CONTROLLED INCINERATION OR
SANITARY LANDFILL. DISPOSAL METHOD MUST BE IAW FEDERAL, STATE AND
LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:FLEXICARB HR, HS, TP HOMOG ROLL AND SHEET T
CAGE:58156
CAGE:58156
============= Composition/Information on Ingredients =============
Ingred Name:GRAPHITE, NATURAL
CAS:7782-42-5
RTECS #:MD9659600
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15 MPPCF RDUST
ACGIH TLV:2 MG/M3 RDUST; 9293
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NONHAZARDOUS
Explanation of Carcinogenicity:NONE
Effects of Overexposure:NONHAZARDOUS
Medical Cond Aggravated by Exposure:NONE
======================= First Aid Measures =======================
First Aid:INHALED: REMOVE PERSON TO FRESH AIR. EYES: FLUSH WITH WATER
FOR 15 MINUTES. SEE DOCTOR. SKIN: WASH WITH SOAP AND WATER.
INGESTED: CALL DOCTOR.
===================== Fire Fighting Measures =====================
Extinguishing Media:MEDIA APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP AND PLACE IN CONTAINER FOR DISPOSAL.
Neutralizing Agent:NONE
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP DRY.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED.
Ventilation:USE ADEQUATE MECHANICAL VENTILATION.
Other Protective Equipment:NONE
Work Hygienic Practices:WASH HANDS AFTER USE AND BEFORE EATING,
DRINKING, OR SMOKING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:GASKET
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:HIGHLY 0XIDIZING ENVIRONMENTS MAY INDUCE
RED-OX REACTION
Hazardous Decomposition Products:OXIDES OF CARBON
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:1-COAT, TT-P-2756, 14052, P/C 03GN271
Kit Part:Y
Preparer's Name:NORM GAUL
CAGE:5M511
CAGE:33461
CAGE:5M511
============= Composition/Information on Ingredients =============
Ingred Name:PROPYLENE GLYCOL MONOMETHYL ETHER ACETATE (VAPOR PRESSURE
3.7 MM @ 68F)
CAS:108-65-6
RTECS #:AI8925000
Fraction by Wt: <5%
Other REC Limits:MFR: 100 PPM
Ingred Name:N-BUTYL ACETATE (VAPOR PRESSURE 13 MM HG @ 68F)
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: 10%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:150 PPM;STEL 200 PPM
ACGIH TLV:150 PPM;STEL 200 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:XYLENE (SARA III) (VAPOR PRESSURE 21 MM HG @ 100F)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 0.31%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM;STEL 150 PPM
ACGIH TLV:100 PPM;STEL 150 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:MINERAL SPIRITS (VAPOR PRESSURE 2 MM HG @ 68F) (NIOSH
LIMIT: 350 MG/M3 - 8 HR TWA; 1800 MG/M3 - 15 MINUTE SAMPLE)
CAS:64475-85-0
RTECS #:PY8240000
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:DISPERSION AID (VAPOR PRESSURE 0 MM HG)
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:ANTI-FLOAT AGENT
CAS:1317-65-3
RTECS #:EV9580000
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 MP/F3
ACGIH TLV:10 MP/F3
Ingred Name:METHYL PROPYL KETONE (VAPOR PRESSURE 27.8 MM HG @ 68F)
CAS:107-87-9
RTECS #:SA7875000
Fraction by Wt: 10%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:200 PPM;STEL 250 PPM
ACGIH TLV:200 PPM;STEL 250 PPM
Ingred Name:2-4 PENTANEDIONE (VAPOR PRESSURE 6.9 MM HG @ 68F)
CAS:123-54-6
RTECS #:SA1925000
Fraction by Wt: <5%
Other REC Limits:UNION CARBIDE:20 PPM
Ingred Name:FLOW AGENT (VAPOR PRESSURE 0 MM HG)
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:ETHYL 3-ETHOXYPROPIONATE (VAPOR PRESSURE 0.7 MM HG @ 68F)
CAS:763-69-9
RTECS #:UF3325000
Fraction by Wt: <1%
Other REC Limits:50 PPM; STEL 100 PPM
Ingred Name:DIBUTYLTIN DILAURATE (VAPOR PRESSURE 0.2 MM HG @ 320F)
CAS:77-58-7
RTECS #:WH7000000
Fraction by Wt: <0.1%
Other REC Limits:NONE RECOMMENDED
ACGIH TLV:0.1 MG/M3
Ingred Name:ANTI MAR AGENT (VAPOR PRESSURE 0 MM HG)
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:ETHYL BENZENE (SARA III) (VAPOR PRESSURE 7.1 MM HG @ 68F)
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: 0.08%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM;STEL 125 PPM
ACGIH TLV:100 PPM;STEL 125 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:VOC: 291 G/L
RTECS #:9999999VO
Other REC Limits:NONE RECOMMENDED
Ingred Name:BARIUM SULFATE (THIS PRODUCT CONTAINS A BARIUM COMPOUND,
58.8% BY WEIGHT)
CAS:7727-43-7
RTECS #:CR0600000
Fraction by Wt: 6.34%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL: RESP TRACT IRRIT & ACUTE
NERVOUS SYSTEM DEPRESSION
(HEADACHE,DIZZINESS,STAGGERING,CONFUSION,UNCONSCIOUSNESS,COMA).
SKIN: IRRIT (SWELLING,REDNESS,RASH). ABSORPTION:IRRIT,DRYING,DEFAT.
EYE:IRRIT (TEARING,REDNESS,SWELLING W/STING).INGEST:IRRIT,
CORROSIVE IN GI TRACT. VOMIT MAY CAUSE ASPIRATION--CHEM
PNEUMONITIS.
Effects of Overexposure:ACUTE:EYES, NOSE, THROAT IRRIT. INHAL:HEADACHE,
DIFFICULT BREATHING, UNCONSCIOUSNESS. CHRONIC:PROLONGED CONTACT
WILL CAUSE DRYING & CRACKING OF SKIN, DUE TO DEFATTING ACTION. SKIN
SENSITIZATION, ASTHM A OR OTHER ALLERGIC RESPONSES MAY DEVELOP.
HARMFUL IF SWALLOWED/ABSORBED THROUGH SKIN. MAY CAUSE LIVER &
KIDNEY DAMAGE.
Medical Cond Aggravated by Exposure:ASTHMA AND ANY OTHER RESPIRATORY
DISORDERS. SKIN ALLERGIES, ECZEMA AND DERMATITIS.
======================= First Aid Measures =======================
First Aid:INHALATION: MOVE TO FRESH AIR. RESTORE BREATHING. ASTHMATIC
TYPE SYMPTOMS MAY DEVELOP (IMMEDIATE OR DELAYED BY SEVERAL HOURS).
GET MEDICAL AID. SKIN: REMOVE CONTAMINATED CLOTHING. WASH AFFECTED
AREAS WITH SOAP & WATER. EYES: FLUSH WITH LUKEWARM WATER (LOW
PRESSURE) 15 MIN, LIFTING EYELIDS. GET MEDICAL AID. INGESTION: DO
NOT INDUCE VOMITING. NOTHING BY MOUTH TO UNCONSCIOUS PERSON. GET
MEDICAL AID.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:46.0F,7.8C
Lower Limits:0.90
Upper Limits:13.10
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG,
WATER SPRAY
Fire Fighting Procedures:WEAR FULL FIRE FIGHTING EQUIP W/SCBA & FULL
PROTECTIVE CLOTHING. USE WATER TO COOL CLOSED CONTAINERS TO PREVENT
PRESSURE BUILD-UP, AUTO IGNITION, OR EXPLOSION.
Unusual Fire/Explosion Hazard:KEEP CNTNR CLSD. KEEP FROM HEAT/IGNIT
SOURCE. CLSD CNTNR MAY EXPLODE W/HEAT. APPLIC TO HOT SURFACE REQ
SPECIAL PRECAUTION. OVEREXPOSURE TO DECOMP PROD-HLTH HZD.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE ALL NON-ESSENTIAL PERSONNEL. REMOVE
ALL SOURCES OF IGNITION. VENTILATE AREA. CONTAIN AND REMOVE WITH
INERT ABSORBENT AND NON-SPARKING TOOLS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN BLDGS IN COMPLY W/OSHA
1910.106,IN VENTD AREA,IN CLOSED CONTAINER.DON'T STORE NEAR HIGH
TEMP/IGNIT SOURCES.PREVENT PROLONGED BREATHING VAPOR.
Other Precautions:KEEP CONTAINERS TIGHT & UPRIGHT (PREVENT LEAK).
PROLONGED OVEREXPOSURE MAY CAUSE ALLERGIC REACTION. AVOID SKIN &
EYE CONTACT. DON'T INGEST. DON'T HANDLE TILL MFR PRECAUTIONS
READ/UNDERSTOOD.SMOKE IN S MOKING AREAS ONLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESPIRATOR RECOMMENDED FOR ORGANIC VAPOR
ENVIRONMENT (AIR PURIFYING/FRESH AIR SUPPLIED) OBEY OSHA REGS FOR
RSPRTR USE. PROVIDE VENT TO KEEP BELOW OSHA LIMITS. IF MAINTAIN
BELOW PEL/TLV, OTHER OSHA/NIO SH APPROVED RSPRTR MAY BE USED.
Ventilation:EXHAUST VENTILATION SUFFICIENT TO KEEP VAPOR CONCENTRATIONS
BELOW TLVS. REMOVE ALL IGNITION SOURCES.
Other Protective Equipment:THE USE OF LONG SLEEVE AND LONG LEG CLOTHING
IS RECOMMENDED. REMOVE AND WASH CONTAMINATED CLOTHING BEFORE REUSE.
Work Hygienic Practices:WASH HANDS BEFORE EATING, SMOKING, OR USING
WASHROOM.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:213 TO 401F
Vapor Density:> AIR
Spec Gravity:1.28571
Viscosity:*
Evaporation Rate & Reference:1.15 X N-BUTYL ACETATE
Solubility in Water:INSOLUBLE
Appearance and Odor:GREEN LIQUID WITH SOLVENT ODOR
Percent Volatiles by Volume:33.7
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HIGH TEMPERATURES, SPARKS, OR OPEN FLAMES.
Hazardous Decomposition Products:BY HIGH HEAT/TEMPERATURE: CARBON
MONOXIDE, CARBON DIOXIDE, AND OXIDES OF NITROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE MUST BE DISPOSED OF IN ACCORDANCE WITH
FEDERAL, STATE, AND LOCAL ENVIRONMENTAL CONTROL REGULATIONS. EMPTY
CONTAINERS MUST BE HANDLED WITH CARE (RESIDUE IS FLAMMABLE). DO NOT
INCINERATE CLOSED CO NTAINERS. EPA HZD CODE: D001, F003, F005.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:METHYLENE BLUE (TB QUICK STAIN KIT)
CAGE:22790
CAGE:22790
============= Composition/Information on Ingredients =============
Ingred Name:METHANOL
CAS:67-56-1
RTECS #:PC1400000
= Wt:1.5
OSHA PEL:260 MG/M3;200 PPM
ACGIH TLV:262 MG/M3;200 PPM
ACGIH STEL:328 MG/M3;250 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ETHANOL
CAS:64-17-5
RTECS #:KQ6300000
= Wt:28.5
OSHA PEL:1900 MG/M3;1000 PPM
ACGIH TLV:1880 MG/M3;1000 PPM
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL RAT LD50: 5628MG/KG METHANOL
Health Hazards Acute and Chronic:SKIN/EYES: NO IRRITATION EFFECT.
SENSITIZATION: NO SENSITIZING EFFECT KNOWN.
Explanation of Carcinogenicity:NOT PROVIDED ON THE MSDS
Effects of Overexposure:NOT PROVIDED
Medical Cond Aggravated by Exposure:NOT PROVIDED
======================= First Aid Measures =======================
First Aid:INHALATION: SUPPLY FRESH AIR; CONSULT DOCTOR IN CASE OF
COMPLAINTS. SKIN: IMMEDIATELY WASH WITH WATER AND SOAP AND RINSE
THOROUGHLY. EYE: RINSE OPENED EYE FOR SEVERAL MINUTES UNDER RUNNING
WATER. THEN CONSULT A DOCTOR. SWALLOWING: CALL A DOCTOR
IMMEDIATELY. INFORMATION FOR DOCTOR. SHOW THIS LABEL.
===================== Fire Fighting Measures =====================
Flash Point:=29.C, 84.2F
Lower Limits:7.0
Upper Limits:20.0
Extinguishing Media:CO2, EXTINGUISHING POWDER OR WATER SPRAY. FIGHT
LARGER FIRES WITH WATER AND ALCOHOL RESISTANT FOAM.
Fire Fighting Procedures:WEAR SELF CONTAINED RESPIRATORY PROTECTIVE
DEVICE. WEAR FULLY PROTECTIVE SUIT.
Unusual Fire/Explosion Hazard:PRODUCT IS NOT EXPLOSIVE. HOWEVER,
FORMATION OF EXPLOSIVE AIR/VAPOR MIXTURES ARE POSSIBLE.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. KEEP UNPROTECTED
PERSONS AWAY. WIPE UP WITH DAMP SPONGE OR MOP. ABSORB WITH
LIQUID-BINDING MATERIAL (SAND, DIATOMITE, ACID BINDERS, UNIVERSAL
BINDERS.)
Neutralizing Agent:NOT PROVIDED
======================Handling and Storage ======================
Handling and Storage Precautions:ENSURE GOOD VENTILATION/EXHAUSTION AT
THE WORKPLACE. KEEP IGNITION SOURCES AWAY. PROTECT AGAINST
ELECTROSTATIC CHARGES. DO NOT SMOKE NEAR MATERIAL. .STORE AWAY
FROM OXIDIZING AGENTS. STORE IN COOL, DRY CONDITIONS IN WELL
SEALED RECEPACLES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IN CASE OF BRIEF EXPOSURE, USE CHEMICAL FUME
HOOD OR NIOSH/MESHA APPROVED RESPIRATOR. IN CASE OF INTENSIVE OR
LONG EXPOSURE, USE RESPIRATORY PROTECTIVE EQUIPMENT THAT IS
INDEPENDENT OF CIRCULATING AIR
Ventilation:AREA VENTILATION IS GENERALLY ADEQUATE. LOCAL EXHAUST
PROPERLY USED AT THE SOURCE OF AIRBORNE GENERATION GENERALLY
PROVIDES THE BEST CONTROL.
Other Protective Equipment:PROTECTIVE WORK CLOTHING (LAB COAT)
Work Hygienic Practices:ALWAYS FOLLOW GOOD HYGIENIC WORK PRACTICES.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:=79.C, 174.2F
Melt/Freeze Pt:M.P/F.P Text:UNDETERMINED
Decomp Temp:Decomp Text:NOT PROVIDED
Vapor Pres:59
Vapor Density:N/D
Viscosity:NOT PROVIDED
Evaporation Rate & Reference:NOT PROVIDED
Solubility in Water:SOLUBLE
Appearance and Odor:BLUE LIQUID; CHARACTERISTIC ODOR
Percent Volatiles by Volume:NOT PROVIDED
Corrosion Rate:NOT PROVIDED
================= Stability and Reactivity Data =================
INCOMPATIBLE MATERIALS, STRONG OXIDIZERS.
Hazardous Decomposition Products:NOTROGEN OXIDES(NOX), CARBON MONOXIDE
(CO) AND CARBON DIOXIDE(CO2), HYDROGEN CHLORIDE (HCL).
=================== Toxicological Information===================
Toxicological Information:ORAL LD50 ETHANOL: 3450 MG/KG MOUSE - ORAL;
LD50 ETHANOL: 7060MG/KG(RAT); ORAL LD50 METHANOL: 5628 MG/KG RAT
===================== Ecological Information =====================
Ecological:NOT PROVIDED
==================== Disposal Considerations ====================
Waste Disposal Methods:NOT PROVIDED
=================== MSDS Transport Information ===================
Transport Information:NOT PROVIDED
===================== Regulatory Information =====================
SARA Title III Information:NOT PROVIDED
Federal Regulatory Information:NOT PROVIDED
State Regulatory Information:NOT PROVIDED
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MID-GRADE GASOLINE
CAGE:2Y744
CAGE:2Y744
============= Composition/Information on Ingredients =============
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: < 25% %
Other REC Limits:NONE RECOMMENDED
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: < 20% %
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:METHYL TERT-BUTYL ETHER (SARA III)
CAS:1634-04-4
RTECS #:KN5250000
Fraction by Wt: < 10% %
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:BENZENE (SARA III)
CAS:71-43-2
RTECS #:CY1400000
Fraction by Wt: < 5% %
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1PPM/5STEL;1910.1028
ACGIH TLV:10 PPM; A2; 9293
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:HEXANE (N-HEXANE)
CAS:110-54-3
RTECS #:MN9275000
Fraction by Wt: < 5% %
Other REC Limits:NONE RECOMMENDED
OSHA PEL:500 PPM
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:CYCLOHEXANE (SARA III)
CAS:110-82-7
RTECS #:GU6300000
Fraction by Wt: < 5% %
Other REC Limits:NONE RECOMMENDED
OSHA PEL:300 PPM
ACGIH TLV:300 PPM, 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ETHYL BENZENE (SARA III)
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: < 5% %
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM/125 STEL
ACGIH TLV:100 PPM/125STEL 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:NAPHTHALENE (SARA III)
CAS:91-20-3
RTECS #:QJ0525000
Fraction by Wt: < 5% %
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 PPM/15 STEL
ACGIH TLV:10 PPM/15 STEL; 9293
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NOT SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:EYE IRRITATION, PROLONGED OR REPEATED
CONTACT MAY CAUSE SKIN IRRITATION, CENTRAL NERVOUS SYSTEM
DEPRESSION, PULMONARY EDEMA, BRONCHITIS, PNEUMONITIS.
Explanation of Carcinogenicity:PRODUCT MAY CONTAIN UP TO 4.9% BENZENE
WHICH IS CLASSIFIED AS CARCINOGENIC TO HUMANS.
Effects of Overexposure:EYE IRRITATION, SKIN DEFATTING/DRYING,
HEADACHE, DIZZINESS, LOSS OF APPETITE, WEAKNESS, LOSS OF
COORDINATION, CONVULSIONS, DELERIUM, HALLUCINATIONS, NUMBNESS IN
THE EXTREMITITES, LOSS OF DEEP TENDON R EFLEXES.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH IMMEIDATELY WITH WATER FOR 15 MINUTES. IF
IRRITATION PERSISTS, CONTACT PHYSICIAN. SKIN: WASH WITH SOAP AND
WATER. SEE DOCTOR IF IRRITATION PERSISTS. INHALATION: REMOVE TO
FRESH AIR. IF NEC ESSARY RESUSCITATE. CAL A PHYSICIAN IMMEDIATELY.
INGESTION: DO NOT INDUCE VOMITING. IF VOMITING OCCURS, KEEP HEAD
BELOW HIPS; ASPIRATION HAZARD. CALL A PHYSICIAN IMMEIDATELY.
===================== Fire Fighting Measures =====================
Flash Point:<-49F,<-45C
Lower Limits:1.4 %
Upper Limits:7.6 %
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM, WATER FOG
Fire Fighting Procedures:DO NOT ENTER ENCLOSED OR CONFINED FIRE SPACE
WITHOUT PROPER PERSONAL PROTECTIVE EQUIPMENT. USE SCBA TO PROTECT
AGAINST TOXIC FUMES AND DEPLETION OF OXYGEN.
Unusual Fire/Explosion Hazard:LIQUID EVAPORATES VERY QUICKLY, EVEN AT
LOW TEMPERATURES AND FORMS VAPORS WHICH CAN CATCH FIRE AND BURN
WITH EXPLOSIVE VIOLENCE. VAPORS MAY TRAVEL AND IGNITE.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL SOURCES OF IGNITION IN VICINITY.
CLEAN UP SMALL SPILLS USING ABSORBENT MATERIALS OR PUMPING. WHERE
FEASIBLE AND APPROPRIATE REMOVE CONTAMINATED SOIL. FOLLOW
PRESCRIBED PROCEDURES FOR REP ORTING AND RESPONDING TO LARGER
SPILLS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT USE OR STORE NEAR FLAME, SPARKS
OR HOT SURFACES. USE AND STORE ONLY IN COOL, WELL VENTILATED AREA.
KEEP CONTAINER CLOSED.
Other Precautions:NEVER SPIHON BY MOUTH. DO NOT TRANSFER LIQUID TO AN
UNLABELED CONTAINER. DO NOT WELD, HEAT OR DRILL CONTAINER. REPLACE
CAP OR BUNG. EMPTIED CONTAINER STILL CONTAINS HAZARDOUS OR
EXPLOSIVE VAPOR OR LIQ UID.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF VENTILATION DOES NOT MAINTAIN INHALATION
EXOSURES BELOW PEL (TLV), USE NIOSH/MSHA APPROVED RESPIRATOR AS PER
CURRENT 29 CFR 1910.134, INSTRUCTIONS/WARNINGS AND NIOSH RESPIRATOR
SELECTION.
Ventilation:USE ONLY IN WELL VENTILATED AREAS
Other Protective Equipment:IMPERIVOUS CLOTHING
Work Hygienic Practices:WASH WITH SOAP AND WATER AFTER HANDLING PRODUCT
AND BEFORE EATING DRINKING OR SMOKING.
Supplemental Safety and Health
AVOID PROLONGED BREATHING OF VAPOR. NOTES TO PHYSICIAN: INGESTION OF
THIS PRODUCT OR SUBSEQUENT VOMITING CAN RESULT IN ASPIRATION OF
LIGHT HYDROCARBON LIQUID WHICH CAN CAUSE PNEUMONITIS.
================== Physical/Chemical Properties ==================
HCC:F1
Boiling Pt:=25.C, 77.F
B.P. Text:25-225C
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Vapor Pres:5-15 PSI
Vapor Density:3-4
Spec Gravity:0.7 - 0.8
Evaporation Rate & Reference:NOT GIVEN
Solubility in Water:INSOLUBLE
Appearance and Odor:CLEAR TO YEOOW LIQUID, CHARACTERISTIC GASOLINE ODOR
Percent Volatiles by Volume:99+
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING MATERIALS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NORMAL COMBUSTION FORMS CARBON DIOXIDE
AND WATER VAPOR. INCOMPLETE COMBUSTION CAN PRODUCE CARBON MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT, RESIDUE, DISPOSAL CONTAINER OR
LINER IN ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PIPERONYL BUTOXIDE TECH 90%, 29110-2
CAGE:60928
CAGE:60928
============= Composition/Information on Ingredients =============
Ingred Name:TOLUENE,
ALPHA-(2-(2-BUTOXYETHOXY)ETHOXY)-4,5-(METHYLENEDIOXY)-2-PROPYL-;(PI
PERONYL BUTOXIDE)
CAS:51-03-6
RTECS #:XS8050000
Fraction by Wt: 90%
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD5O: (ORL-RAT) 6150 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY BE FATAL IF INHALED, SWALLOWED, OR
ABSORBED THROUGH SKIN.MAY CAUSE IRRITATION.TO THE BEST OF OUR
KNOWLEDGE, THE CHEMICAL, PHYSICAL, AND TOXICOLOGICAL PROPERTIES
HAVE NOT BEEN THOROUGHLY INVESTIGAT ED.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:REMOVE CONTAMINATED CLOTHING AND SHOES.EYES:FLUSH W/COPIOUS
AMOUNTS OF WATER FOR AT LEAST 15 MINUTES.INHALATION:REMOVE TO FRESH
AIR.IF NOT BREATHING GIVE ARTIFICIAL RESPIRATION.IF BREATHING IS
DIFFICU LT, GIVE OXYGEN.INGESTION:WASH OUT MOUTH W/WATER PROVIDED
PERSON IS CONSCIOUS.CALL A PHYSICIAN. DISCARD CONTAMINATED
SHOES.INGESTION OF LGE AMNTS CAUSES VOMITING/DIARRHEA.
===================== Fire Fighting Measures =====================
Flash Point:>230
Extinguishing Media:WATER SPRAY, CO*2, DRY CHEMICAL POWDER,
ALCOHOL/POLYMER FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED RESPIRATOR APPROPRATE
FOR EXPOSURE OF CONCERN. WEAR PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:EVAC AREA.WEAR NIOSH/MSHA APPRVD SCBA,RUB
USE.COVER W/DRY LIME/SODA ASH,PICK UP,KEEP IN CLOSED CNTNR-HOLD FOR
WASTE DISPOSAL.VENT AREA &WASH SPILL SITE AFTER MAT PICKUP IS
COMPLETE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE ONLY IN A CHEMICAL FUME HOOD.DO
NOT BREATHE VAPOR.AVOID CNTCT W/EYES,SKIN,& CLOTHING.AVOID
PRLNG/REPEATED EXPSR.WASH THOROUGHLY AFTER HANDLING.
Other Precautions:TOXIC.POSSIBLE CARCINOGEN.KEEP TIGHTLY CLOSED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT.
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH THOROUGHLY,SAFETY SHOWER AND EYE BATH.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:T6
Boiling Pt:B.P. Text:311F,155C
Spec Gravity:1.059
Appearance and Odor:VISCOUS YELLOW LIQUID
================= Stability and Reactivity Data =================
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:TOXIC FUMES OF: CO, CO*2
==================== Disposal Considerations ====================
Waste Disposal Methods:DISSOLVE OR MIX THE MATERIAL WITH A COMBUSTIBLE
SOLVENT AND BURN IN A CHEMICAL INCINERATOR EQUIPPED W/AFTERBURNER &
SCRUBBER.OBSERVE ALL FEDERAL, STATE AND LOCAL ENVIRONMENTAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:EASY BLEND NEUTRAL FLOOR CLEANER #1
CAGE:12120
CAGE:12120
============= Composition/Information on Ingredients =============
Ingred Name:2-BUTOXYETHANOL (SARA 313)
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: <5.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:25 PPM SKIN
ACGIH TLV:25 PPM SKIN
Ingred Name:NONYLPHENOXYPOLYETHYLENEOXYETHANOL
CAS:9016-45-9
RTECS #:MD0900000
Other REC Limits:NONE RECOMMENDED
Ingred Name:VOC = 35 G/L
RTECS #:9999999VO
Fraction by Wt: NA
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT RELEVANT
ACGIH TLV:NOT RELEVANT
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Effects of Overexposure:EYES: REDNESS, TEARING. INHALATION: NAUSEA,
HEADACHE, IRRITATED NASAL PASSAGES. INGESTION: GI DISTURBANCES.
SKIN: REDNESS, DRYNESS, IRRITATION.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH THOROUGHLY W/WATER. REMOVE CONTACTS & CONTINUE
FLUSHING AT LEAST 15 MIN. IF IRRIT OCCURS GET MED AID. INHALATION:
GET TO FRESH AIR. IF SYMPTOMS PERSIST GET MED AID. INGESTION: DRINK
LOTS W ATER CALL DR/POISON CONTROL CENTER IMMED. NEVER GIVE
ANYTHING BY MOUTH OR INDUCE VOMITING IF PERSON UNCONSCIOUS. SKIN:
WASH THOROUGHLY W/SOAP & WATER. IF IRRIT PERSISTS GET MED AID.
===================== Fire Fighting Measures =====================
Flash Point:NA
Lower Limits:NA
Upper Limits:NA
Extinguishing Media:NA
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:MOP UP MATERIAL OR PICK UP W/ABSORBENT
MATERIAL. RINSE W/WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP OUT OF REACH OF CHILDREN.
Other Precautions:FOLLOW NORMAL HYGIENE PRACTICES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE
Ventilation:LOCAL EXHAUST.
Other Protective Equipment:EYEWASH, PROTECTIVE CLOTHING
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:ABOUT 212F
Vapor Pres:NA
Vapor Density:NA
Spec Gravity:8.3
pH:6-6.7
Evaporation Rate & Reference:NA
Solubility in Water:COMPLETE
Appearance and Odor:AMBER LIQUID, HONEYSUCKLE ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NK
Stability Condition to Avoid:NA
Hazardous Decomposition Products:OXIDES OF CARBON
==================== Disposal Considerations ====================
Waste Disposal Methods:FOLLOW ALL FEDERAL, STATE & LOCAL WASTE
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:A86 W14 PURE WHITE BASE X, SUPER PAINT
CAGE:54636
CAGE:54636
============= Composition/Information on Ingredients =============
Ingred Name:ETHYLENE GLYCOL, GLYCOL
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: <5%
Other REC Limits:10 MG/CUM
ACGIH TLV:C 127 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SILICA DIOXIDE, CRYSTALLINE QUARTZ, SAND (SUSPECTED HUMAN
CARCINOGEN BY IARC)
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 0-20%
Other REC Limits:0.05 MG/CUM NIOSH
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
Ingred Name:SILICA CRYSTALLINE, SILICA (CRISTOBALITE) (SUSPECTED HUMAN
CARCINOGEN BY IARC)
CAS:14464-46-1
RTECS #:VV7325000
Fraction by Wt: 0-5%
Other REC Limits:0.05 MG/CUM NIOSH
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.05 MG/M3 RDUST9293
Ingred Name:TALC (POWDER), (ASBESTOS FREE), TALCUM; HYDROUS MAGNESIUM
SILICATE
CAS:14807-96-6
RTECS #:WW2710000
Fraction by Wt: 0-5%
OSHA PEL:20 MPPCF
ACGIH TLV:2 MG/CUM (RESP DUST)
Ingred Name:TITANIUM DIOXIDE, TITANIUM(IV) OXIDE, TIO2
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 0-15%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:WEIGHT PER GALLON IN POUNDS: 9.6-11.7
RTECS #:9999999WG
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:INHALATION: UPPER RESPIRATORY SYSTEM
IRRITATION, HEADACHE, NAUSEA OR DIZZINESS. SKIN/EYES: IRRITATION,
REDNESS, ITCHING OR BURNING SENSATION.
Explanation of Carcinogenicity:SILICA QUARTZ, SILICA CRISTOBALITE ARE
SUSPECTED HUMAN CARCINOGENS.
Effects of Overexposure:INHALATION: ADVERSE EFFECTS TO THE REPRODUCTIVE
SYSTEMS, DUST MAY CAUSE LUNG DAMAGE (SILICOSIS) & POSSIBLY CANCER.
SKIN/EYES: IRRITATION, REDNESS, ITCHING OR BURNING SENSATION.
======================= First Aid Measures =======================
First Aid:INHALATION: IF AFFECTED, REMOVE FROM EXPOSURE. RESTORE
BREATHING. KEEP WARM/QUIET. SKIN: WASH AFFECTED AREA THOROUGHLY
W/SOAP & WATER. EYES: FLUSH W/PLENTY OF WATER FOR 15 MINS. OBTAIN
MEDICAL ATTENTI ON IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>199F
Extinguishing Media:CO2, DRY CHEMICAL, ALCOHOL FOAM
Fire Fighting Procedures:USE FULL PROTECTIVE EQUIP & SCBA. WATER SPRAY:
INEFFECTIVE. FOG NOZZLES: PREFERABLE. USE WATER TO COOL FIRE
EXPOSED CONTAINERS TO PREVENT PRESSURE BUILD-UP.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY BUILD-UP PRESSURE,
EXPLODE OR AUTOIGNITE WHEN EXPOSED TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE &
REMOVE W/INERT ABSORBENT.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED WHEN NOT IN USE.
TRANSFER ONLY TO APPROVED CONTAINERS W/COMPLETE & APPROPRIATE
LABELING. DON'T TAKE INTERNALLY.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. AVOID CONTACT W/SKIN,
EYES & BREATHING VAPOR & SPRAY MIST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE A NIOSH/MSHA APPROVED PROPERLY FITTED
ORGANIC VAPOR/PARTICULATE RESPIRATOR. USE A NIOSH/MSHA APPROVED
DUST/MIST RESPIRATOR WHEN SANDING OR ABRADING THE DRIED FILM.
Ventilation:LOCAL EXHAUST: PREFERABLE. GENERAL EXHAUST: ACCEPTABLE
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH HANDS AFTER USING.
Supplemental Safety and Health
BOILING RANGE: 212-388F.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:SEE SUPP
Vapor Density:>AIR
pH:8.3-10
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:61-81%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:EXTREME HEAT OR OTHER SOURCES OF IGNITION
Hazardous Decomposition Products:CO2, CO
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE IN APPROVED FACILITY. DON'T
INCINERATE CLOSED CONTAINER. DISPOSE OF IN ACCORDANCE W/LOCAL,
STATE & FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:EUGENOL
CAGE:41946
CAGE:41946
============= Composition/Information on Ingredients =============
Ingred Name:EUGENOL
CAS:97-53-0
RTECS #:SJ4375000
Fraction by Wt: 100%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and
Chronic:ACUTE-EYES:IRRITATION.SKIN:IRRITATION.INHALATION:IRRITATION
.INGESTION:GASTROINTESTINAL IRRITATION.CHRONIC:NONE SPECIFIED BY
MANUFACTURER.
Effects of Overexposure:EYE, SKIN IRRITATION; LIVER DAMAGE; LOCAL
ANALGESIA; GASTROENTERITIS;PERIPHERAL VASCULAR COLLAPSE.
Medical Cond Aggravated by Exposure:LIVER DISEASE; SKIN DISORDER; EYE
DISEASE
======================= First Aid Measures =======================
First Aid:INHALATION:REMOVE TO FRESH AIR.RESUSCITATE IF NOT
BREATHING.GET MEDICAL ATTENTION.EYES:IMMEDIATELY FLUSH WITH PLENTY
OF WATER FOR 15 MINUTES.GET MEDICAL ATTENTION.SKIN:WASH WITH SOAP
AND WATER.INGESTI ON:DILUTE WITH WATER OR MILK, THEN EMESIS IF
INDICATED, ACTIVATED CHARCOAL AND A SALINE CATHARTIC SHOULD BE
ADMINISTERED.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:230F,110C
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:USE WATER SPRAY TO COOL CONTAINERS EXPOSED TO
FIRE.
Unusual Fire/Explosion Hazard:NONE, MATERIAL IS NOT PYROPHORIC REACT
WITH WATER; NOT AN OXYGEN DONOR; MATERIAL IS SHOCK STABLE.
================== Accidental Release Measures ==================
Spill Release Procedures:WIPE/SOAK UP WITH PAPER RAGS AND PLACE
CONTAMINATED ITEMS IN CLOSED METAL WASTE CONTAINER.
Neutralizing Agent:NOT APPLICABLE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY, WELL VENTILATED
AREA. KEEP CONTAINERS TIGHTLY CLOSED.EUGENOL DARKENS AND THICKENS
UPON EXPOSURE TO AIR.
Other Precautions:NONE, JUST FOLLOW GOOD MANUFACTURING PRACTICE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AVOID CASUAL BREATHING OF VAPOR.
Ventilation:LOCAL EXHAUST
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
INDUSTRIAL-TYPE WORK CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
AVOID PROLONGED OR REPEATED EXPOSURE. DO NOT GET ON SKIN OR IN EYES. DO
NOT BREATHE VAPORS OR MISTS.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:487F,253C
Vapor Pres:0.1
Spec Gravity:1.064-1.070
pH:UNKNON
Solubility in Water:SLIGHT
Appearance and Odor:COLORLESS TO PALE YELLOW LIQUID WITH ODOR OF CLOVES
AND PUNGENT,SPICY,OILY.
Percent Volatiles by Volume:UNKNON
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:EXCESSIVE HEAT.
Hazardous Decomposition Products:CARBON MONOXIDE AND CARBON DIOXIDE
UPON BURNING.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL SHOULD BE MADE IN ACCORDANCE WITH ALL
APPLICABLE FEDERAL, STATE AND LOCAL LAWS AND REGULATIONS.
| 1 | gloves_mandatory |
=======================================================
Product ID: KELTON ELASTOMER,509X100
Cage: TO547
Box: 2591
Resp. Party Other MSDS No.: CR 2260 (R 5/93)
=======================================================
Contractor Summary
=======================================================
Cage: TO546
Box: 2591
Cage: TO547
Box: 2591
=======================================================
Ingredients
=======================================================
Cas: 25034-71-3
% Wt: WT 75% MAX
-----------------------------
Cas: 64741-88-4
RTECS #: PY8040500
% Wt: WT 60% MAX
------------------------------
Cas: 64742-01-4
% Wt: SEE ING #2
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: LD50= >15G/KG (RAT); LC50=N/A (NOTE 2)
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: NO ACUTE OR CHRONIC HAZARDS OR EFFECTS ARE KNOWN. EYE
CONTACT: NOT A PROBABLE ROUTE OF EXPOSURE. PARTICULATES MAY SCRATCH EYE
SURFACE OR CAUSE IRRITATION. SKIN CONTACT: A SINGLE PROLONGED EXPOSURE IS
NOT LIKELY TO RESULT IN MATERIAL BEING ABSORBED THROUGH THE SKIN IN HARMFUL
AMOUNTS. REPEATED PROLONGED EXPOSURE MAY CAUSE MILD SKIN IRRITATION IN SOME
INDIVIDUALS. EXPOSURE TO HOT MATERIALS MAY CAUSE THERMAL BURNS. INGESTION:
NOT A PROBABLE ROUTE OF EXPOSURE. INHALATION: NOT A PROBABLE ROUTE OF
EXPOSURE UNDER CONDITIONS OF NORMAL USE. HOT FUMES/VAPORS WHICH MAY FORM
DURING PROCESSING CAN CAUSE IR RITATION TO THE UPPER RESPIRATORY TRACT.
Explanation Of Carcinogenicity: CARCINOGENICITY: NONE REPORTED
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS (FP N).
Medical Cond Aggravated By Exposure: SOME INDIVIDUALS WITH SPECIFIC
SENSITIVITIES MAY EXIBIT EYE, NOSE, THROAT OR THERMAL IRRITATION WITH
PROLONGED EXPOSURE TO PROCESSING FUMES OR VAPORS.
First Aid: EYE CONTACT: REMOVE AS FOR ANY FOREIGN OBJECT. FLUSH WITH CLEAN
WATER FOR 15 MINUTES. OBTAIN MEDICAL ATTENTION IF IRRITATION PERSISTS. SKIN
CONTACT: WASH WITH SOAP AND WATER. IF THERMAL IRRITATION, F LUSH AFFECTED
AREA WITH COLD WATER TO DISSIPATE HEAT, THEN COVER WITH CLEAN COTTON SHEETING
OR GAUZE AND GET PROMPT MEDICAL ATTENTION. INHALATION: IF FUMES/VAPORS ARE
INHALED, MOVE TO FRESH AIR, AID BREATHING IF NECESSARY. OBTAIN MEDICAL
ATTENTION IF IRRITATION PERSISTS. INGESTION: UNLIKELY TO OCCUR.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: REPACKAGE UNCONTAMINATED RUBBER. REUSE OR DISPOSE OF
(SEE DISPOSAL INFORMATION) IF CONTAMINATED.
Waste Disposal Methods: REUSE IF POSSIBLE. DISPOSE IN ACCORDANCE WITH LOCAL,
STATE, AND FEDERAL REGULATIONS AND APPLICABLE ENVIRONMENTAL REGULATIONS.
MATERIALS AS SUPPLIED ARE NOT CHARACTERIZED AS HAZARDOUS UNDER RCRA.
Handling And Storage Precautions: STORE BELOW 35C (95F) IN DRY AREA AND IN THE
ABSENCE OF DIRECT, NATURAL, OR ARTIFICIAL LIGHT.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: COC
Flash Point: =240.C, 464.F
Flash Point Text: SEE NOTE 2
Autoignition Temp: =350.C, 662.F
Autoignition Temp Text: - 380C
Extinguishing Media: ALL FIRE EXTINGUISHING MEDIA PERMITTED - FOAM OR WATER FOG
RECOMMENDED
Fire Fighting Procedures: DURING EMERGENCY CONDITIONS, EXPOSURE TO THERMAL
DECOMPOSITION PRODUCTS MAY CAUSE A HEALTH HAZARD. USE OF NIOSH APPROVED SELF
CONTAINED BREATHING APPARATUS IS RECOMMENDED.
Unusual Fire/Explosion Hazard: NOT COMBUSTIBLE, BUT THE PRODUCT WILL BURN IF
IGNITED. IGNITION TEMPERATURE: ABOVE 200C (392F). SENSITIVITY TO
IMPACT/SHOCH: N/A. SENSITIVITY TO STATIC DISCHARGE: N/A. UPPER/LOWER
FLAMMABLE LIMITS: NOT ESTABLISHED.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NOT NORMALLY REQUIRED AT AMBIENT TEMPERATURES. IF
PROCESSING IN AREA WHERE VENTILATION IS INADEQUATE, WEAR A NIOSH APPROVED
ORGANIC VAPOR RESPIRATOR WITH MECHANICAL FILTRATION.
Ventilation: LOCAL EXHAUST VENTILATION IS RECOMMENDED DURING ALL HOT PROCESSING
OPERATIONS.
Other Protective Equipment: WEAR CLOTHING APPROPRIATE TO PREVENT SKIN CONTACT.
WHERE CONTACT MAY OCCUR WITH HOT MATERIAL, WEAR ARM PROTECTION AND A FACE
SHIELD. EYEWASH & DELUGE SHOWER MEETING ANSI DESIGN CRITERIA (FP N).
Work Hygienic Practices: AVOID SKIN AND EYE CONTACT, PRACTICE GOOD PERSONAL
HYGIENE. AVOID INHALATION OF FUMES/VAPORS FROM HOT RUBBERS, COMPOUNDS AND
VULCANIZATES.
Supplemental Safety and Health: NFPA FIRE HAZARDS IDENTIFICATION SYSTEMS:
HEALTH = 0, FIRES = 1, REACTIVITY = 0, SPECIFIC = 0.ODOR THRESHOLD: NOT
ESTABLISHED.COEFFICIENT IN WATER/OIL DISTRIBUTION: NOT ESTABLISHED.
CHEMICAL NAME : ETHYLENE PROPYLENE DIENE TERPOLYMER RUBBER, OIL-EXTENDED.
CAS NUMBER: MIXTURE-N/A.
=======================================================
Physical/Chemical Properties
=======================================================
Spec Gravity: 0.86 - 0.87
Solubility in Water: INSOLUABLE (AT 20C)
Appearance and Odor: PALE YELLOW TO AMBER SOLID, BALES WITH SLIGHT ODOR
Percent Volatiles by Volume: 0.75-1.0(WT
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: PRODUCT IS STABLE AT AMBIENT TEMPERATURE AND
PRESSURE. HIGH TEMPERATURES, 300-350C (572-662F) WILL CAUSE THERMAL
DECOMPOSITION; IGNITION SOURCE.
Materials To Avoid: NONE KNOWN.
Hazardous Decomposition Products: CARBON MONOXIDE, CARBON DIOXIDE, VARIOUS
HYDROCARBONS, AND PRODUCTS FROM INCOMPLETE COMBUSTION.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: WILL NOT OCCUR.
=======================================================
Toxicological Information
=======================================================
Toxicological Information: REPRODUCTIVE EFFECTS: NONE REPORTED.
TERATOGENICITY: NONE REPORTED. MUTAGENICITY: NONE REPORTED.OTHER: SKIN
IRRITANT: LD50 > 8000 MG/KG, RABBIT (SEE NOTE 2).EXPOSURE GUIDELINES:
PETROLEUM OIL AS OIL MIST (SEE NOTE 3): PEL (OSHA), 5 MG/M3; TLV (ACGIH), 5
MG/M3.
=======================================================
Ecological Information
=======================================================
Ecological: N/P. OTHER INFO (CONT): IN THIS PRODUCT. THE PETROLEUM OIL IS
SOLUABLE IN THE EPDM COMPONENT AND DATA ON THE BLEND HAS NOT BEEN
ESTABLISHED.NOTE 3: SPECIFIC EXPOSURE STANDARDS FOR THIS PRODUCT AND ITS
COMPONENTS HAVE NOT BEEN ESTABLISHED. THE LIMITS SHOWN IN (TOXICOLOGICAL
INFO) ARE SUGGESTED AS MINIMUM CONTROL GUIDELINES. THESE EXPOSURE LIMITS
APPLY ONLY IF AEROSOLS ARE EMITTED FROM THIS PRODU CT.
=======================================================
=======================================================
Transport Information: DOT: UNITED STATES: DESIGNATION AND LABELING NOT
APPLICABLE AS PRODUCT IS NOT DEFINED OR DESIGNATED AS A HAZARDOUS MATERIAL BY
U.S. DEPARTMENT OF TRANSPORTATION UNDER TITLE 49 OF CFR. CANADA: THIS PR
ODUCT IS NOT REGULATED UNDER CANMADA'S TRANSPORTATION OF DANGEROUS GOODS
REGULATIONS.
=======================================================
Regulatory Information
=======================================================
Sara Title III Information: SECTION 302/304 EXTREMELY HAZARDOUS SUBSTANCES -
NONE. SECTION 311 HAZARDOUS SUBSTANCES - NOT APPLICABLE. SECTION 313: THIS
PRODUCT IS NOT SUBJECT TO REPORTING REQUIREMENTS (SEE 40 CFR 372).
Federal Regulatory Information: OSHA: THE PETROLEUM OIL COMP IN THIS PRODUCT,
IF PRESENT AS AN OIL MIST, IS REGULATED UNDER HAZARD COMMUNICATION STANDARD
29 CFR PART 1910.1200 (SEE NOTE 3). TSCA: COMPONENTS OF THIS PRODUCT ARE LIS
TED UNDER TSCA CHEMICAL SUBSTANCE INVENTORY.FDA: GRADES P557, P558, P597,
5531D CAN BE USED IN COMPLYING W/ 21 CFR 177.2600, 'RUBBER ARTICLES INTENDED
FOR REPEATED USE'. W: THIS PRODUCT IS NOT CONSIDERED A CONTROLLED PRODUCT
UNDER CANADA'S WORKPLACE HAZARDOUS MATERIAL INFORMATION SYSTEM. CEP A:
COMPONENTS OF THIS PRODUCT ARE INCLUDED IN CANADA'S DSL. EEC: THIS PROD IS
NOT CONSIDERED HAZARDOUS BY THE EUROPEAN ECONOMIC COMMUNITY.
=======================================================
Other Information
=======================================================
Other Information: LABELS:
OSHA: N/A. WHIMIS: N/A. PRODUCT USE:RUBBER AND RUBBER MODIFIED ARTICLES.
MSDS SUPERCEDES: CR 2260 (R 9/90). HAZARD CLASSIFICATION: NH. NOTE 1:THIS
PARTICULAR GRADE OF PARAFFINIC OIL IS BL ENDED FROM THE SEVERELY SOLVENT
REFINED HEAVY PARAFFINIC DISTILLATE CAS #64741-88-4 AND THE SEVERELY SOLVENT
REFINEDDISTILLATE CAS #64742-01-4. IT CONTAINS LESS THAN 0.1 WEIGHT PERCENT
POLYNUCLEAR ARO MATIC COMPOUNDS AND IS THEREFORE NOT CONSIDERED AS
CARCINOGENIC UNDER HAZARD COMMUNICATION STANDARD TITLE 29 CFR 1910.1200.
NOTE 2: THIS DATA REPRESENTS THE LOWEST POSSIBLE LIMIT AND IS FOR THE PETRO
LEUM OIL INGREDIENT (ECOLOGICAL INFO)
=======================================================
HAZCOM Label
=======================================================
Product ID: KELTON ELASTOMER,509X100
Cage: TO547
Assigned IND: Y
Company Name: DSM COPOLYMER INC
Street: 5955 SCENIC HWY
PO Box: 2591
Zipcode: 70821
Label Required IND: Y
Date Of Label Review: 04/13/2000
Status Code: A
Origination Code: F
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: NO ACUTE OR CHRONIC HAZARDS OR EFFECTS ARE KNOWN. EYE
CONTACT: NOT A PROBABLE ROUTE OF EXPOSURE. PARTICULATES MAY SCRATCH EYE
SURFACE OR CAUSE IRRITATION. SKIN CONTACT: A SINGLE PROLONGED EXPOSURE IS
NOT LIKELY TO RESULT IN MATERIAL BEING ABSORBED THROUGH THE SKIN IN HARMFUL
AMOUNTS. REPEATED PROLONGED EXPOSURE MAY CAUSE MILD SKIN IRRITATION IN SOME
INDIVIDUALS. EXPOSURE TO HOT MATERIALS MAY CAUSE THERMAL BURNS. INGESTION:
NOT A PROBABLE ROUTE OF EXPOSURE. INHALATION: NOT A PROBABLE ROUTE OF
EXPOSURE UNDER CONDITIONS OF NORMAL USE. HOT FUMES/VAPORS WHICH MAY FORM
DURING PROCESSING CAN CAUSE IR RITATION TO THE UPPER RESPIRATORY TRACT.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:NOX RUST X-116
Preparer's Name:J. KUKSUK
CAGE:7X108
CAGE:7X108
============= Composition/Information on Ingredients =============
Ingred Name:SOLVENT NAPHTHA (PETROLEUM) MEDIUM ALIPHATIC
CAS:64742-88-7
Fraction by Wt: 40-43%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
Ingred Name:PETROLEUM HYDROCARBON,
CAS:64742-47-8
RTECS #:OA5504000
Fraction by Wt: 40-43%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
Ingred Name:STODDARD SOLVENT
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 40-43%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:500 PPM
ACGIH TLV:100 PPM; 9596
Ingred Name:PETROLEUM HYDROCARBON DISTILLATE OR ALIPHATIC PETROLEUM
SOLVENT
CAS:8008-20-6
RTECS #:OA5500000
Fraction by Wt: <4%
Other REC Limits:NONE RECOMMENDED
Ingred Name:OXIDIZED ALIPHATIC PETROLEUM FRACTION
CAS:64743-01-7
Fraction by Wt: 30-35%
Other REC Limits:2 MG/M3 (WAX FUMES)
Ingred Name:PETROLEUM OIL
Fraction by Wt: <4%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
Ingred Name:CALCIUM HYDROXIDE
CAS:1305-62-0
RTECS #:EW2800000
Fraction by Wt: <2%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:5 MG/M3; 9596
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EXCESSIVE INHALATION MAY
PRODUCE DIZZINESS, NAUSEA, HEADACHE AND INCOORDINATION. MAY CAUSE
REVERSIBLE EYE & SKIN IRRITATION. PROLONGED SKIN EXPOSURE MAY CAUSE
DERMATITIS OR OIL ACNE. BREATHING MISTS MAY CAUSE DIZZINESS OR
PULMONARY IRRITATION. CHRONIC: NOT DETERMINED.
Explanation of Carcinogenicity:NO INGREDIENT OF A CONCENTRATION OF 0.1%
OR GREATER IS LISTED AS A CARCINOGEN OR SUSPECTED CARCINOGEN.
Effects of Overexposure:INHALED-DIZZINESS, NAUSEA, HEADACHE,
INCCORDINATION, PULMONARY IRRITATION. EYES-IRRITATION.
SKIN-IRRITATION, DERMATITIS, OIL ACNE.
Medical Cond Aggravated by Exposure:EXPOSURE MAY AGGRAVATE PRE-EXISTING
RESPIRATORY OR SKIN PROBLEMS.
======================= First Aid Measures =======================
First Aid:IN ALL CASES GET MEDICAL ATTENTION. EYES-FLUSH WITH WATER FOR
15 MINUTES. SKIN-REMOVE CONTAMINATED CLOTHES. WASH WITH MILD SOAP &
WATER. INHALED-REMOVE TO FRESH AIR. ADMINISTER OXYGEN OR ARTIFICIAL
RE SPIRATION AS NEEDED. INGESTED-CONSULT APHYSICIAN. IF VOMITING
OCCURS SPONTANEOUSLY, KEEP HEAD BELOW HIPS TO PREVENT ASPIRATION OF
LIQUID INTO LUNGS.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:105F,41C
Lower Limits:0.6
Upper Limits:7.0
Extinguishing Media:WATER FOG, CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:MOVE CONTAINER FROM AREA IF FEASIBLE. WEAR
SELF-CONTAINED BREATHING APPARATUS AND FULL PROTECTIVE GEAR. COOL
FIRE EXPOSED CONTAINERS WITH WATER.
Unusual Fire/Explosion Hazard:MAY BE IGNITED BY HEAT,SPARKS OR FLAMES.
VAPORS MAY TRAVEL TO SOURCE OF IGNITION & FLASH BACK.CONTAINER MAY
EXPLODE IN FIRE.RUNOFF MAY POSE EXLOSION/FIRE HAZARD
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL SOURCES OF IGNITION; NO FLARES,
SMOKING OR FLAMES IN HAZARD AREA. STOP LEAK IF FEASIBLE. TAKE UP
WITH SAND OR OTHER NONCOMBUSTIBLE ABSORBENT MATERIAL. PLACE IN A
CONTAINER FOR LATER DISP OSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY, WELL-VENTILATED
PLACE. KEEP AWAY FROM SOURCES OF IGNITION SOURCES. NEVER USE A
TORCH TO CUT OR WELD ON OR NEAR CONTAINER.
Other Precautions:EMPTY CONTAINERS CAN CONTAIN EXPLOSIVE VAPORS.NEVER
WEAR CONTAMINATED CLOTHES.LAUNDER OR DRY CLEAN CLOTHING BEFORE
WEARING.DISCARD OIL-SOAKED SHOES.WASH THOROUGHLY WITH SOAP & WATER
AFTER USE & BEFORESMOKING OR EATING.AVOID SKIN CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF ENGINEERING CONTROLS FAIL OR NON-ROUTINE USE
OR AN EMERGENCY OCCURS; WEAR AN MSHA/NIOSH APPROVED RESPIRATOR WITH
ORGANIC VAPOR CARTRIDGE OR AN AIR-SUPPLIED RESPIRATOR OR SCBA, AS
REQUIRED. USE IAW 29 CFR 1910.134.
Ventilation:GENERAL & LOCAL EXHAUST.
Other Protective Equipment:IF SPLASHING ANTICIPATED, WEAR RUBBER
APRON/BOOTS OR OTHER PROTECTIVE EQUIPMENT TO MINIMIZE CONTACT.
Work Hygienic Practices:WASH HANDS AFTER HANDLING AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health
EPA HAZARD CLASS (40 CFR 370): DELAYED (CHRONIC), FIRE (COMBUSTIBLE).
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:>300F,>149C
Vapor Pres:3.4
Vapor Density:>1
Spec Gravity:0.87
Evaporation Rate & Reference:<1 (N-BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:DARK AMBER, VISCOUS LIQUID; PETROLEUM SOLVENT ODOR.
Percent Volatiles by Volume:50
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG ACIDS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON MONOXIDE AND CARBON DIOXIDE,
MISCELLANEOUS HYDROCARBONS.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL ENVIRONMENTAL REGULATIONS. MATERIALS MAY BECOME HAZARDOUS
WASTE THROUGH USE. IF PERMITTED, INCINERATION MAY BE PRACTICED.
CONSIDER RECYCLING SOLV ENT. EPA HAZWASTE NUMBER=D001.
| 1 | gloves_mandatory |
=======================================================
Product ID: 28-0111 BRUNING PD ACTIVATOR 22-761012
Cage: 0SL27
Proprietary Ind: Y
=======================================================
Preparer Co. when other than Responsible Party Co.
=======================================================
Cage: 0SL27
=======================================================
Contractor Summary
=======================================================
Cage: 9Y119
Cage: 0SL27
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: ORAL LD50(RAT): 3500 MG/KG
Route Of Entry Inds - Inhalation: YES
Skin: NO
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: EYES: MAY CAUSE EXTREME IRRITATION/DAMAGE. SKIN: MAY CAUSE
EXTREME IRRITATION, BURNS, DERMATITIS. INHALATION: MAY CAUSE MARKED
IRRITATION OF NOSE, THROAT & LUNGS. INGESTION: MAY CAUSE DIGESTIVE TRACT
IRRITATION. AMES TESTS OF MIXTURE WERE NEGATIVE, INDICATING NO MUTAGENIC
ACTIVITY.
Explanation Of Carcinogenicity: NONE
Signs And Symptions Of Overexposure: IRRITATION, BURNS, ITCHING, DEFATTING,
DRYNESS OF THROAT.
First Aid: EYES: IRRIGATE W/LARGE AMOUNTS OF RUNNING WATER FOR 15 MINS. SKIN:
WASH W/SOAP & WATER. INHALATION: REMOVE TO FRESH AIR. OBTAIN MEDICAL
ATTENTION IN ALL CASES.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: MOP/FLUSH W/WATER & BLOT W/TOWELS. WEAR
Waste Disposal Methods: INCINERATION, SMALL QUANTITIES MAY BE DILUTED &
FLUSHED DOWN DRAIN IAW/FEDERAL, STATE & LOCAL REGULATIONS.
Other Precautions: DON'T RUB EYES AFTER CONTACT W/FLUID. AVOID PUNCTURING
CONTAINERS. WHEN REPAIRING/SERVICING EQUIPMENT, USE SAME PRECAUTIONS FOR
HANDLING CONTAMINATED PARTS AS RECOMMENDED FOR FLUID.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: PMCC
Flash Point Text: 233F
Extinguishing Media: WATER, CO2, DRY POWDER.
Fire Fighting Procedures: WEAR A SCBA.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NOT REQUIRED UNLES FIGHTING FIRES.
Ventilation: MECHANICAL (GENERAL): SUFFICIENT TO PREVENT ODORS & TO HANDLE
HEAT PRODUCED BY PD COPY MACHINE USED.
Work Hygienic Practices: WASH THOROUGHLY AFTER HANDLING/CONTACT.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: 216-650F
Vapor Pres: <1
Vapor Density: 3
Spec Gravity: 1.05
PH: 11
Solubility in Water: COMPLETE
Appearance and Odor: CLEAR, PALE YELLOW LIQUID W/NO DISTINCT ODOR.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: OPEN FLAME & HIGH TEMPS.
Materials To Avoid: STRONG ACIDS & OXIDIZING AGENTS.
Hazardous Decomposition Products: BY FIRE/REACTION W/STRONG OXIDIZING AGENTS:
OXIDES OF CARBON & NITROGEN.
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: 28-0111 BRUNING PD ACTIVATOR 22-761012
Cage: 0SL27
Company Name: OCE-BRUNING INC
Street: 1800 BRUNING DRIVE W
Zipcode: 60143
Label Required IND: Y
Date Of Label Review: 12/16/1998
Status Code: C
Label Date: 12/16/1998
Origination Code: G
Hazard And Precautions: EYES: IRRITATION OR DAMAGE. SKIN: ITCHING, IRRITATION,
BURNS, DEFATTING, & DERMATITIS. INHALATION: DRYNESS OF THROAT. NOSE,
THROAT, & LUNG IRRITATION. INGESTION: DIGESTIVE TRACT IRRITATION.
EYES:
IRRITATION OR EYE DAMAGE. SKIN: ITCHING, IRRITATION, BURNS, DEFATTING, &
DERMATITIS. INHALATION: DRYNESS OF THE THROAT. NOSE,THROAT, & LUNG
THROAT. INGESTION: DIGESTIVE TRACT IRRITATION.
=======================================================
| 1 | gloves_mandatory |
=======================================================
Product ID: INTERNAL STANDARDS FOR NOVA FLUIDS PACKS, 15-107
Cage: IO886
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 15481
Box: 1546
Cage: IO886
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: NO
Skin: NO
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: TOXIC BY INGESTION, IRRITATING TO EYES AND SKIN BUT NOT A
SENSITIZER. IRRITATION OF EYES AND SKIN.
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: NONE INDICATED.
First Aid: INHAL:REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTF RESP)
(FP N). EYES:FLUSH WITH COPIOUS AMOUNTS OF WATER FOR AT LEAST 15 MINUTES (FP
N). INGEST:CALL MD IMMEDIATELY (FP N). SKIN:FLUSH WITH CO PIOUS AMOUNTS OF
WATER (FP N).
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: MAY BE SWEPT UP AND DISPOSED OF WITH NORMAL LAB
TRASH.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: MAY BE DISPOSED OF WITH NORMAL LAB TRASH. FOLLOW ALL
FEDERAL, STATE, AND LOCAL REGULATIONS.
Handling And Storage Precautions: NONE INDICATED
Other Precautions: NOT REQUIRED UNDER NORMAL PRODUCT USAGE.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Extinguishing Media: WATER, FOAM, DRY CHEMICAL, CO*2
Fire Fighting Procedures: NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: NONE
=======================================================
Control Measures
=======================================================
Respiratory Protection: NOT REQUIRED UNDER NORMAL PRODUCT USAGE.
Ventilation: NOT REQUIRED UNDER NORMAL PRODUCT USAGE.
Other Protective Equipment: NOT REQUIRED UNDER NORMAL PRODUCT USAGE.
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: DECOMPOSES
M.P/F.P Text: 266F,130C
Vapor Pres: NIL
Solubility in Water: @ 22C APPROX 25%
Appearance and Odor: WHITE CRYSTALS; SLIGHT CHARACTERISTIC ODOR.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products: NOT INDICATED
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: INTERNAL STANDARDS FOR NOVA FLUIDS PACKS, 15-107
Cage: IO886
Assigned IND: Y
Company Name: PHOENIX DIAGNOSTICS INC
Street: 8 TECH CIRCLE
Zipcode: 01760
Label Required IND: Y
Date Of Label Review: 09/29/1994
Status Code: C
Label Date: 09/29/1994
Origination Code: G
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE: TOXIC BY INGESTION, IRRITATING TO EYES AND SKIN
BUT NOT A SENSITIZER. IRRITATION OF EYES AND SKIN. CHRONIC:NONE LISTED BY
MANUFACTURER.
=======================================================
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:SUPERKOTE PRIMER UNDERCOAT 37-11 WHITE
Preparer's Name:THOMAS E. MAREK
CAGE:33200
CAGE:33200
============= Composition/Information on Ingredients =============
Ingred Name:STODDARD SOLVENT; (MINERAL SPIRITS) VP:2.0
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 28.0%
OSHA PEL:500 PPM
ACGIH TLV:100 PPM MG/M3
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES:CAN CAUSE SEV IRRIT, REDNESS,
TEARING, BLURRED VISION. SKIN:PRLNGD/RPTD CONT CAN CAUSE MOD IRRIT,
DEFAT, DERM. INHAL:EXCESSIVE INHAL OF VAPS CAN CAUSE NASAL & RESP
IRRIT, DIZZ, WEAK, FATG, NAUS, HDCH, POSS UNCONSCIOUSNESS, & EVEN
ASPHYXIATION. INGEST:CAN CAUSE GI IRRIT, NAUS, VOMIT & DIARR. (EFTS
OF OVEREXPOS)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZS:ASPIR INTO LUNGS CAN CAUSE CHEM
PNEUMOITIS WHICH CAN BE FATAL. SIGNS & SYMPTOMS:DIZZ, NAUS, SKIN OR
EYE IRRIT OR UNCONSCIOUSNESS.
Medical Cond Aggravated by Exposure:NONE KNOWN
======================= First Aid Measures =======================
First Aid:SKIN:THORO WASH EXPOSED AREA W/SOAP & WATER. REMOVE CONTAM
CLTHG & LAUNDER BEFORE REUSE. EYES:FLUSH W/LG AMTS OF WATER FOR AT
LST 15 MIN, LIFTING UPPER & LOWER LIDS OCCAS, GET MED ATTN.
INGEST:DO NOT INDUCE VOMIT. KEEP PERSON WARM & GET MED ATTN.
INHAL:REMOVE TO FRESH AIR. IF BRTHG IS DFCLT, ADMIN OXYGEN. IF
BRTHG HAS STOPPED, APPLY ARTF RESP. KEEP PERSON WARM, QUIET & GET
MED ATTN.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:102F,39C
Lower Limits:1.0%
Upper Limits:6.0%
Extinguishing Media:FOAM, DRY CHEMICAL, CARBON DIOXIDE
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:VAPS ARE HEAVIER THAN AIR AND MAY TRAVEL
ALONG GROUND OR BE MOVED BY VENT AND IGNITED BY SOURCES OF IGNIT AT
LOCATIONS DISTANT FROM MATL HANDLING POINT.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB LIQUID ON PAPER, VERMICULITE, FLOOR
ABSORBANT OR OTHER ABSORBANT MATERIAL AND PICK UP WITH SHOVEL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID PROLONGED OR REPEATED SKIN
CONTACT. KEEP AWAY FROM HEAT, SPARKS, OPEN FLAMES. USE WITH
ADEQUATE VENTILATION.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SELF CONTAINED NIOSH/MSHA APPROVED RESPIRATOR IF
TLV IS REACHED.
Ventilation:LOCAL EXHAUST AS NEEDED TO REMAIN BELOW PEL.
Other Protective Equipment:BARRIER CREAM, EYE BATH AND ANSI APPRVD
SAFETY SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:300F,149C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:1.36 (H*2O=1)
Evaporation Rate & Reference:70 (ETHER=1)
Solubility in Water:NONE
Appearance and Odor:WHITE OPAQUE LIQUID, MINERAL SPIRITS ODOR.
Percent Volatiles by Volume:50.6
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:EXCESSIVE HEAT, SPARKS, OPEN FLAME.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY YIELD CARBON
DIOXIDE AND/OR CARBON MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:128 4181 RAPID ACCESS DEVELOPER & REPLENIS
CAGE:19139
CAGE:19139
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 65-70%
Ingred Name:POTASSIUM SULFITE
CAS:10117-38-1
Fraction by Wt: 15-20%
Ingred Name:HYDROQUINONE (SARA III)
CAS:123-31-9
RTECS #:MX3500000
Fraction by Wt: 6%
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3; 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SODIUM CARBONATE
CAS:5968-11-6
Fraction by Wt: 1-5%
Ingred Name:POTASSIUM HYDROXIDE (SARA III)
CAS:1310-58-3
RTECS #:TT2100000
Fraction by Wt: 1-5%
OSHA PEL:C, 2 MG/M3
ACGIH TLV:C 2 MG/M3; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: LOW HAZARD FOR RECOMMENDED
HANDLING. EYE: LIQUID MAY CAUSE IRRITATION. SKIN: PROLONGED OR
REPEATED SKIN CONTACT MAY CAUSE IRRITATION. MAY CAUSE AN ALLERGIC
SKIN REACTION. INGESTION: HARMF UL IF SWALLOWED.
Explanation of Carcinogenicity:SUPPLIER DID NOT ADDRESS THIS FIELD.
Effects of Overexposure:EYE: IRRITATION. SKIN: IRRITATRION. INGESTED:
HARMFUL INHALED: LOW HAZARD.
Medical Cond Aggravated by Exposure:SUPPLIER DID NOT ADDRESS THIS
FIELD.
======================= First Aid Measures =======================
First Aid:EYES:IMMEDIATELY FLUSH WITH PLENTY OF WATER AT LEAST FOR 15
MINUTES & GET MED ATTN; SKIN:FLUSH WITH LARGE AMOUNTS OF WATER FOR
AT LEAST 15 MIN. REMOVE CONTAMINATED CLOTHES AND LAUNDER BEFORE
REUSE. IF SKIN IRRITATION OR ALLERGIC REACTION DEVELOPS,GET MED
ATTN; INGESTION:INDUCE VOMITING AS DIRECTED BY MEDICAL PERSONNEL.
NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. CALL A
PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:NOT FLAMMABLE
Extinguishing Media:USE APPROPRIATE AGENT FOR SURROUNDING FIRE
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:FIRE CONDITIONS MAY CAUSE GENERATION OF
HAZARDOUS DECOMPOSITATION PRODUCTS.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH NEUTRALIZED MATERIAL TO ACID FREE SEWER
WITH LARGE AMOUNTS OF WATER.
Neutralizing Agent:SODIUM BISULFATE
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER TIGHTLEY CLOSED AND
AWAY FROM STRONG ACIDS.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESPIRATORY PROTECTION MAY BE NEEDED IN SPECIAL
CIRCUMSTANCES.
Ventilation:GOOD VENTILATION ( 10 ROOM VOL PER HOUR IS CONSIDERED GOOD
GENERAL VENTILATION). SUPPLEMENTAL VENTILATION MAY BE NEEDED.
Other Protective Equipment:ROUTINE USE OF A NON-ALKALINE TYPE SKIN
CLEANER WILL MINIMIZE POSSIBILITY OF ALLERGIC SKIN REACTION.
Work Hygienic Practices:REMOVE CONTAMINATED CLOTHING AND LAUNDER BEFORE
REUSE. CISCARTD OR THOROUGHLY CLEAN CONTAMINATED SHOES.
Supplemental Safety and Health
IS HIGHLY ALKALINE AND EXPECTED TO HAVE MODERATE BOD. EXPECTED TO HAVE
HIGH POTENTIAL TO AFFECT AQUATIC ORGANISMS AND LOW FOR WASTE
TREATMENT MICROORGANISMS. A FINAL CONCENTRATION OF 0.08 MG/L IS NOT
EXPECTED TO CAUSE AN ADVERSE ENVIRONMENTAL EFFECT AFTER TREATMENT.
================== Physical/Chemical Properties ==================
HCC:B3
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:>212F,>100C
Melt/Freeze Pt:M.P/F.P Text:NOT RELEVAT
Vapor Pres:18 MM
Vapor Density:0.60
Spec Gravity:1.22
pH:11.0
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR,OFF-WHITE,ODORLESS SOLUTION
Percent Volatiles by Volume:65
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STROMG MINERAL ACIDS
Stability Condition to Avoid:SUPPLIER DID NOT ADDRESS THIS FIELD.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY PRODUCE
OXIDES OF SULFUR.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE , TREATMENT, OR DISPOSAL MAY BE
SUBJECT TO FEDERAL, STATE, OR LOCAL LAWS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:1503 ANTIQUE WHITE DECORATOR PAINTS
CAGE:DO642
CAGE:DO642
CAGE:09800
============= Composition/Information on Ingredients =============
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 13%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT; 9394
Ingred Name:ISOBUTANE
CAS:75-28-5
RTECS #:TZ4300000
Fraction by Wt: 13%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:200 PPM; Z-2
ACGIH TLV:S, 50 PPM; 9394
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 12%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/150STEL;9394
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ACETONE (SARA III)
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 19%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1000PPM
ACGIH TLV:750PPM/1000STEL;9394
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 2%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:200 PPM
ACGIH TLV:200 PPM/300STEL 9394
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 9%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9394
Ingred Name:BARIUM SULFATE
CAS:7727-43-7
RTECS #:CR0600000
Fraction by Wt: 11%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9394
Ingred Name:VOLATILE ORGANIC COMPOUND [AS WT/% PER MAAQMD RULE 49]
RTECS #:9999999VO
Fraction by Wt: 64%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION MAY CAUSE
RESPIRATORY IRRITATION OR CNS DEPRESSION. CONTACT MAY CAUSE SKIN
AND EYE IRRITATION. NO HEALTH EFFECTS GIVEN FOR INGESTION. CHRONIC:
PROLONGED OR REPEATED EXPOSURE MAY CAUS E DAMAGE TO LIVER, URINARY,
BLOOD-FORMING, CARDIOVASCULAR AND CENTRAL NERVOUS SYSTEMS.
Explanation of Carcinogenicity:NO INGREDIENT OF A CONCENTRATION OF 0.1%
OR GREATER IS LISTED AS A CARCINOGEN OR SUSPECTED CARCINOGEN.
Effects of Overexposure:INHALED: HEADACHE, DIZZINESS, NAUSEA, LOSS OF
COORDINATION, SHORTNESS OF BREATH. EYES: REDNESS, TEARING, BURNING
SENSATION. SKIN: REDNESS, DISCOMFORT. NO SYMPTOMS GIVEN FOR
INGESTION BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.
======================= First Aid Measures =======================
First Aid:INHALED: REMOVE FROM EXPOSURE TO FRESH AIR. RESTORE
BREATHING. KEEP WARM QUIET. GET MEDICAL ATTENTION. EYES: FLUSH
WITH LOTS OF WATER FOR 15 MINUTES. GET MEDICAL AID. SKIN: REMOVE
CONTAMAINATED CLOTH ES. WASH WITH SOAP & WATER. INGESTED: GET
MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:<0F,<-18C
Lower Limits:0.9
Upper Limits:13.1
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECIVE GEAR. WATER MAY BE USED TO COOL FIRE EXPOSED
CONTAINERS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE IF EXPOSED
TO EXTREME HEAT OR OPEN FLAME. DURING EMERGENCY CONDITIONS EXPOSURE
TO DECOMPOSITION PRODUCTS MAY CAUSE A HEALTH HAZARD
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL SOURCES OF IGNITION. VENTILATE
AND REMOVE WITH INERT ABSORBENT. PLACE IN A CONTAINER FOR LATER
DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY, WELL-VENTILATED
PLACE, OUT OF DIRECT SUNLIGHT AND AWAY FROM SOURCES OF IGNITION.
Other Precautions:CONTENTS UNDER PRESSURE. DO NOT PUNCTURE, INCINERATE,
OR EXPOSE TO TEMPERATURES ABOVE 120F. DO NOT TAKE INTERNALLY. KEEP
OUT OF REACH OF CHILDREN. INTENTIONAL MISUSE MAY BE HARMFUL OR
FATAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF ENGINEERING CONTROLS FAIL OR NON-ROUTINE USE
OR EMERGENCY OCCURS; USE NIOSH/MSHA APPROVED RESPIRATOR OR SUPPLIED
AIR RESPIRATOR OR SCBA, AS REQUIRED. USE IAW 29 CFR 1910.134.
Ventilation:USE LOCAL EXHAUST TO MAINTAIN EXPOSURE BELOW TLV.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH HANDS AFTER USE AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health
MSDS ENTERED BY DLA-HMIS UNDER PROJECT WITH AF-FP.
================== Physical/Chemical Properties ==================
HCC:V3
Boiling Pt:B.P. Text:<302F,<150C
Vapor Density:>1
Evaporation Rate & Reference:>1 (ETHER=1)
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER. HMIS- DO
NOT EXPOSED TO DIRECT SUNLIGHT OR OPEN FLAME.
Hazardous Decomposition Products:CARBON MONOXIDE AND CARBON DIOXIDE,
OXIDES OF METALS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. EPA/RCRA WASTE NUMBER D001 MAY APPLY. DO NOT
INCINERATE.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:TILE MASTIC, 406
CAGE:60778
CAGE:60778
============= Composition/Information on Ingredients =============
Ingred Name:PETROLEUM DISTILLATE, BLEND (CONSISTING OF INGS 2 - 6)
RTECS #:9999999ZZ
Fraction by Wt: 34%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:HEXANE; (N-HEXANE)
CAS:110-54-3
RTECS #:MN9275000
OSHA PEL:500 PPM
ACGIH TLV:50 PPM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:CYCLOHEXANE (SARA III)
CAS:110-82-7
RTECS #:GU6300000
OSHA PEL:300 PPM
ACGIH TLV:300 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:HEPTANE; (N-HEPTANE)
CAS:142-82-5
RTECS #:MI7700000
OSHA PEL:500 PPM;500 PPM STEL
ACGIH TLV:400 PPM;500 PPM STEL
Ingred Name:CYCLOHEXANE, METHYL-; (METHYLCYCLOHEXANE)
CAS:108-87-2
RTECS #:GV6125000
OSHA PEL:500 PPM
ACGIH TLV:400 PPM
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
OSHA PEL:200 PPM;150 PPM STEL
ACGIH TLV:50 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 2.5%
OSHA PEL:200 PPM;150 PPM STEL
ACGIH TLV:50 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:FIRST AID PROC:IMMEDIATE MEDICAL ATTENTION. INGEST:DO NOT
INDUCE VOMITING. SEEK IMMEDIATE MEDICAL ADVICE &/OR ATTENTION.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC:HYGIENE PROCEDURES PRIOR TO WORKING W/MATERIAL.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE:THIS PROD MAY BE IRRITANT.
SKIN:PRLNG/RPTD CONT W/THIS PROD MAY CAUSE IRRIT/DERM. INHAL:MAY
CAUSE ANESTH, HDCH, DIZZ, NAUS & UPPER RESP IRRIT. SYSTEMIC
EFTS:RESP TRACT IRRIT; CNS DEPRESS (IN HIGH CONCS). LIVER & KIDNEY
DMG, BRAIN CELL DMG MAY RSLT FROM LONG TERM INHAL OF TOLUENE VAP.
SIGNS & SYMPS (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:OF CNS DEPRESS MAY INCL ONE/MORE OF
FOLLOWING:HDCH, DIZZ, LOSS OF APPETITE, WEAK & LOSS OF COORD.
AFFECTED PERS USUALLY EXPER COMPLETE RECOVERY WHEN REMOVED FROM
EXPOS AREA. PRLNG & RPTD EXPO S TO N-HEXANE MAY DMG PERIPHERAL
NERVE TISS (THAT OF ARMS & LEGS) & RSLT IN MUSCULAR WEAK & LOSS OF
SENSATION IN(SUPDAT)
Medical Cond Aggravated by Exposure:EXPOS TO THIS PROD MAY AGGRAVATE
EXISTING MED CNDTNS SUCH AS:HEART, LIVER, KIDNEY, CNS, RESP, SKIN &
EYE DISORDERS. PERSONS W/SUCH DISORDERS SHOULD CONSULT MD BEFORE
USING THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH W/LG QTYS OF WATER FOR AT LST 15 MINS & SEEK IMMED
MED ATTN. SKIN:WASH W/SOAP & LG QTYS OF WATER; CONSULT MD IF IRRIT
PERSISTS. INHAL:IF BRTHG DFCLTIES, DIZZ/LT HEAD OCCUR WHEN WORKING
IN AR EAS OF HIGH VAP CONCS, VICTIM SHOULD SEEK AIR FREE OF VAPS.
IF VICTIM EXPERS CONTINUED BRTHG DFCLTIES, ADMIN OXYGEN UNTIL MED
ASSISTANCE CAN BE RENDERED. IF BRTHG STOPS BEGIN ARTF RESP & SEEK
(ING 8)
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:<20F,<-7C
Lower Limits:1%
Upper Limits:8%
Extinguishing Media:FOAM, CO*2, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . WATER MAY BE UNSUITABLE EXCEPT AS A COOLING MEDIUM.
Unusual Fire/Explosion Hazard:KEEP AWAY FROM SOURCES OF IGNITION.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH W/WATER INTO RETAINING AREA OR
CONTAINER. SMALL AMOUNTS OF SPILLED MATERIAL MAY BE ABSORBED INTO
AN APPROPRIATE ABSORBANT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY AREA AWAY FROM
SOURCES OF IGNITION. AVOID PROLONGED OR REPEATED PERSONAL CONT &
INHAL OF VAPS.
Other Precautions:KEEP CNTNRS COOL, DRY & AWAY FROM SOURCES OF IGNIT;
USE & STORE W/ADEQ VENT W/AIR MOVEMENT SUFFICIENT TO PVNT BUILD-UP
OF TOX/EXPLO CONCS. PERS USING THIS PROD SHOULD BE MADE AWARE OF
ALL HLTH HAZ DAT A & BE INSTRUCTED IN SAFETY & (ING 9)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:THE USE OF RESPIRATORY PROTECTION DEPENDS ON
VAPOR CONCENTRATIONS ABOVE TLV; USE A NIOSH/MSHA APPROVED CARTRIDGE
RESPIRATOR OR GAS MASK.
Ventilation:LOCAL EXHAUST MAY BE REQUIRED TO MAINTAIN SAFE VAPOR
CONCENTRATIONS.
Other Protective Equipment:IMPERMEABLE APRONS ADVISED; EYE WASHES &
SAFETY SHOWERS IN WORK AREAS ARE RECOMMENDED.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EFTS OF OVEREXP:EXTREMS (PERIPHERAL NEUROPATHY). OVEREXP TO COMPONENTS
HAS BEEN SUGGESTED AS CAUSE OF FOLLOWING EFTS IN HUMANS:LIVER
ABNORMS. NOTE:TOLUENE APPEARS ON NAVY LIST OF OCCUP CHEM REPRO HAZS
. SEEK CONSULTATION FROM APPROP HLTH PROFESSIONALS CONCERNING
LATEST HAZ LIST INFO & SAFE HNDLG & EXPOS INFO .
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:>148F,>64C
Vapor Pres:80 @ 100F
Vapor Density:3.3
Spec Gravity:1.127 (H*2O=1)
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NEGLIGIBLE
Appearance and Odor:GRAY PASTE; SLIGHT ODOR.
Percent Volatiles by Volume:53
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT, SPARKS & OPEN FLAME.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY YIELD CARBON
MONOXIDE & CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF I/A/W LOCAL, STATE & FEDERAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:AEROSHELL OIL W MULTIGRADE 15W/50
Preparer's Name:G.A. VAN GELDER
CAGE:SHELO
CAGE:SHELO
CAGE:54527
============= Composition/Information on Ingredients =============
Ingred Name:1-DECENE HOMOPOLYMER, HYDROGENATED *93-3*
CAS:68037-01-4
Fraction by Wt: 50-60%
Ingred Name:CATALYTIC DEWAXED HEAVY PARAFFINIC OIL
CAS:64742-70-7
RTECS #:PY8045500
Fraction by Wt: 20-30%
Ingred Name:POLYMERIC ADDITIVE
Fraction by Wt: <15%
Ingred Name:T-BUTYLPHENYL DIPHENYL PHOSPHATE *93-3*
CAS:56803-37-3
Fraction by Wt: <1%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION. SKIN: IRRITATION &
DISORDERS SUCH AS DERMATITIS, FOLLICULITIS OR OIL ACNE. INHALATION:
MILD IRRITATION TO UPPER RESPIRATORY TRACT. INGESTION: SLIGHTLY
TOXIC. TRIPHENYL PHOSPHATE, PRE SENT AT <1% IN PRODUCT, MAY CAUSE
CHOLINESTERASE INHIBITION.
Explanation of Carcinogenicity:NONE
Medical Cond Aggravated by Exposure:PREEXISTING SKIN & RESPIRATORY
DISORDERS
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR 15 MINS. SKIN: REMOVE CONTAMINATED
CLOTHING & WIPE OFF EXCESS, WASH W/SOAP & WATER OR WATERLESS HAND
CLEANER. INHALATION: REMOVE TO FRESH AIR & PROVIDE OXYGEN IF
BREATHING IS D IFFICULT. INGESTION: DON'T INDUCE VOMITING. NOTE TO
PHYSICIAN: IF PATIENT SHOWS SIGNS & SYMPTOMS OF CHOLINESTERASE
INHIBITION, TREAT W/ATROPHINE. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:455F
Extinguishing Media:WATER FOG, FOAM, DRY CHEMICAL, CO2. DON'T USE
DIRECT STREAM OF WATER.
Fire Fighting Procedures:DON'T ENTER CONFINED SPACES W/O FULL BUNKER
A POSITIVE-PRESSURE NIOSH APPROVED SCBA.
Unusual Fire/Explosion Hazard:MATERIAL WILL NOT BURN UNLESS PREHEATED.
COOL FIRE EXPOSED CONTAINERS W/WATER. PRODUCT WILL FLOAT & CAN BE
REIGNITED ON SURFACE OF WATER.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR RESPIRATOR & PROTECTIVE CLOTHING. SHUT
OFF SOURCE OF LEAK IF SAFE TO DO. DIKE & CONTAIN. REMOVE W/VACUUM
TRUCK/PUMP TO STORAGE VESSELS. SOAK UP RESIDUE W/ABSORBENT SUCH AS
CLAY/SAND/OTHER SUITABL E MATERIAL. FLUSH AREA W/WATER TO REMOVE
RESIDUE.
======================Handling and Storage ======================
Other Precautions:AVOID SKIN & EYE CONTACT. PROPERLY DISPOSE OF
CONTAMINATED LEATHER ARTICLES, INCLUDING SHOES, THAT CANNOT BE
DECONTAMINATED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED RESPIRATOR SUCH AS AN
ATMOSPHERE-SUPPLYING OR AIR-PURIFYING FOR ORGANIC VAPORS &
PARTICULATES.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH BEFORE EATING/DRINKING/SMOKING/USING TOILET FACILITIES.
Supplemental Safety and Health
VISCOSITY: 117
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:-25F
Spec Gravity:0.8633
Solubility in Water:NEGLIGIBLE
Appearance and Odor:ORANGE OIL W/SLGIHT HYDROCARBON ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIALS
Stability Condition to Avoid:HEAT, OPEN FLAMES
Hazardous Decomposition Products:COMPLEX MIXTURE OF AIRBORNE SOLID,
LIQUID, PARTICULATES & GASES. CO & OTHER UNIDENTIFIED ORGANIC
COMPOUNDS
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:A1177B1
Kit Part:Y
Preparer's Name:C. PEARSON
CAGE:KO011
CAGE:KO011
CAGE:0GGS8
CAGE:1HS43
============= Composition/Information on Ingredients =============
Ingred Name:BISPHENOL A EPICHLOROHYDRIN
CAS:25085-99-8
Fraction by Wt: 75%
Other REC Limits:NONE SPECIFIED
Ingred Name:CALCIUM CARBONATE
CAS:1317-65-3
RTECS #:EV9580000
Fraction by Wt: 25%
Other REC Limits:NONE SPECIFIED
OSHA PEL:10 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:AMORPHOUS SILICA
CAS:112945-52-5
RTECS #:VV7310000
Fraction by Wt: <5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:10 MG/M3
ACGIH TLV:10 MG/3M
Ingred Name:VOC: NONE
RTECS #:9999999VO
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SOME PEOPLE MAY DEVELOP ALLERGIC
REACTION.
Effects of Overexposure:MINOR TRANSIENT IRRITATION OF EYES AND SKIN.
Medical Cond Aggravated by Exposure:SKIN RASHES.
======================= First Aid Measures =======================
First Aid:FLUSH EYE WITH WATER FOR 15 MIN HOLDING EYELIDS OPEN. SEE
PHYSICIAN. WASH SKIN WITH SOAP AND WATER. SEE PHYSICIAN IF RASH
DEVELOPS. REMOVE TO FRESH AIR. GIVE ARTIFICIAL RESPIRATION IF NOT
BREATHING. C ONSULT A PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:480F,249C
Extinguishing Media:WATER FOG, CARBON DIOXIDE, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:DO NOT ENTER CONFINED FIRE SPACE WITHOUT
PROPER PROTECTIVE EQUIPMENT, INCLUDING A NIOSH APPROVED
SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:FIRES MAY GIVE OFF TOXIC FUMES.
================== Accidental Release Measures ==================
Spill Release Procedures:AVOID EYE AND SKIN CONTACT. SCRAPE UP OR
ABSORB AND PLACE IN CONTAINER FOR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL DRY AREA AWAY FRO
SOURCES OF HEAT. KEEP AWAY FROM CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NORMALLY NECESSARY. USE ORGANIC VAPOR FOR
FUMES FROM HEATED MATERIAL.
Ventilation:LOCAL AT A POINT OF CORE OR HEATING.
Other Protective Equipment:EYE WASH AND SHOWER IN AREA.
Supplemental Safety and Health
KEY1;T6.
================== Physical/Chemical Properties ==================
HCC:T6
Boiling Pt:B.P. Text:>400F
Decomp Temp:Decomp Text:>400 F
Spec Gravity:1.371
Viscosity:>100,000CPS
Solubility in Water:NIL
Appearance and Odor:THICK GREEN LIQUID, EPOXY ODOR.
Percent Volatiles by Volume:0.0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS, AMINES IN UNCONTROLLED CONDITIONS.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
PHENOL AND OTHER TOXIC FUMES.
==================== Disposal Considerations ====================
Waste Disposal Methods:THIS MATERAIL IF DISCARDED MAY BE HAZARDOUS.
DISCARD IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS.
INCINERATION IS THE PREFERRED METHOD.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:UCON REFRIGERANT 22
CAGE:6M841
CAGE:6M841
============= Composition/Information on Ingredients =============
Ingred Name:CHLORODIFLUOROMETHANE
CAS:75-45-6
RTECS #:PA6390000
Fraction by Wt: 100%
OSHA PEL:1000 PPM
ACGIH TLV:1000PPM; 9192
Ozone Depleting Chemical:2
===================== Hazards Identification =====================
Effects of Overexposure:LIQUID CONTACT CAUSE FREEZING.BREATHING
CONCENTRATIONS IN EXCESS OF 10% MAY CAUSE DIZZINESS
======================= First Aid Measures =======================
First Aid:FLUSH FROSTED AREA WITH WARM WATER & GET MEDICAL CARE.IF HIGH
GAS CONCENTRATIONS ARE INHALED MOVE TO FRESH AIR
===================== Fire Fighting Measures =====================
Flash Point:NONE
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:ALLOW TO EVAPORATE
======================Handling and Storage ======================
BREATHER.CAUTION:LIQUID & GAS UNDER PRESSURE.KEEP AWAY FROM HEAT OR
OPEN FLAME.DO NOT DROP OR REFILL
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FRESH AIR MASK IN CONFINED AREAS
Ventilation:LOCAL EXHAUST IS PREFERRED.MECHANICAL IS ACCEPTABLE
Other Protective Equipment:EYE BATH & SAFETY SHOWER
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:G3
Boiling Pt:B.P. Text:-41.4F
Vapor Pres:132
Vapor Density:3.0
Spec Gravity:1.21
Evaporation Rate & Reference:500,BUTYL ACETATE
Solubility in Water:0.1%
Appearance and Odor:GAS;CHARACTERISTIC ODOR
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:CHL,HF,CO &/OR CO*2 PRODUCED THRU
THERMAL DECOMPOSITION
==================== Disposal Considerations ====================
Waste Disposal Methods:MIX IN SMALL PROPORTION WITH BURNABLE LIQUID &
INCINERATE UNDER APPROVED CONTROLLED PROCEDURES
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:POLY-TERGENT B-300
CAGE:99530
CAGE:99530
============= Composition/Information on Ingredients =============
Ingred Name:NONYLPHENOXYPOLYETHOXYETHANOL, LD50:3.8 G/KG(RAT),
LC50:>200 MG/L (1HR), EYE & MUCOUS MEMBRANE IRRITATION.
Fraction by Wt:
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50:3.9G/KG(RAT),DERMAL (SUP DAT)
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EFFECTS OF ACUTE EXPOSURE:EYE & MUCOUS
MEMBRANE IRRITATION, DIARRHEA, LETHARGY. EFFECTS OF CHRONIC
EXPOSURE:NONE EXPECTED AT INDUSTRIAL USE LEVELS.
Explanation of Carcinogenicity:NOT APPLICABLE.
Effects of Overexposure:EYE & MUCOUS MEMBRANE IRRITATION, DIARRHEA,
LETHARGY.
Medical Cond Aggravated by Exposure:N/K
======================= First Aid Measures =======================
First Aid:EYE:IMME FLUSH W/LGE AMTS OF WTR FOR AT LEAST 15 MIN,CALL A
PHYSICIAN. SKIN:FLUSH W/WTR.WASHING ANY SUBSTANCE OFF SKIN IS A
GOOD SAFETY PRACTICE. INGESTION:DRINK WATER, INDUCE VOMITING BY
STICKING FIN GER DOWN THROAT.CALL A PHYSICIAN. INHALATION:REMOVE
VICTIM TO FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTIFICIAL
RESPIRATION).
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:550F/287.78C
Lower Limits:N/DETERMINED
Upper Limits:N/DETERMINED
Extinguishing Media:WATER SPRAY, DRY CHEMICAL, FOAM OR CARBON DIOXIDE.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SELF-CONTAINED
BREATHING APPARATUS WHERE THIS MATERIAL IS INVOLVED IN A FIRE.
Unusual Fire/Explosion Hazard:N/K
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR NIOSH/MSHA APPROV ORGANIC VAPOR/MST
ABSORBENT,SHOVEL/SWEEP UP.PLACE IN APPRO CNTNR & SEAL.WASH ALL
CONTAM CLTHNG BFOR REUSE.IN EVEN T OF LGE SPILL,CALL
1-800-OLIN-911.
Neutralizing Agent:N/K .
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT GET IN EYES,ON SKIN/ON
CLOTHING.DO NOT TAKE INTERNALLY.AVOID BREATHING MIST/VAPOR.UPON
CONTACT W/SKIN/EYES WASH OFF W/WTR.STORE IN (SUP DAT)
Other Precautions:N/K
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:NONE BEYOND GOOD ROOM VENTILATION NORMALLY REQUIRED.
Other Protective Equipment:NONE REQUIRED.
Supplemental Safety and Health
HNDLNG/STOR PRCAU:COOL,DRY,WELL-VENT PLACE.LD50-LC50 MIX:LD50:>2
G/KG(RBT),INHAL LC50 >A NOMINAL CONC OF 200 MG/L INSPIRED AIR FOR
1HR.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:NO DATA
Melt/Freeze Pt:M.P/F.P Text:NO DATA
Decomp Temp:Decomp Text:N/K
Vapor Pres:NIL
Vapor Density:NO DATA
Spec Gravity:NO DATA
pH:N/DATA
Evaporation Rate & Reference:NO DATA
Solubility in Water:SOLUBLE
Appearance and Odor:N/K
Percent Volatiles by Volume:N/DATA
Corrosion Rate:
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:HIGH HEAT.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE.
Conditions to Avoid Polymerization:HIGH HEAT
==================== Disposal Considerations ====================
Waste Disposal Methods:DSPOSE OF CONTAM PRODUCT,EMPTY CONTAINERS & MATL
USED IN CLEAN UP SPILLS/LEAKS IN MANNER APPROVED FOR THIS
MATL.CONSULT APPROPRIATE FEDERAL, STATE & LOCAL REGULATORY AGENCIES
TO ASCERTAIN PROPER DISPO SAL PROCEDURES.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PHOSPHORUS 1000 UG/ML (0.1% W/V)
CAGE:0EK28
CAGE:0EK28
============= Composition/Information on Ingredients =============
Ingred Name:PHOSPHORIC ACID
CAS:7664-38-2
RTECS #:TB6300000
Other REC Limits:1 MG/CUM
OSHA PEL:1 MG/CUM
ACGIH TLV:1 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:NITRIC ACID, HYDROGEN NITRATE
CAS:7697-37-2
RTECS #:QU5775000
OSHA PEL:5 MG/CUM
ACGIH TLV:5 MG/CUM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN/EYES: LIQUID MAY CAUSE BURNS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:BURNS, COUGHING, DIFFICULTY BREATHING, NAUSEA,
VOMITING, LOSS OF CONSCIOUSNESS.
======================= First Aid Measures =======================
First Aid:INGESTION; DON'T INDUCE VOMITING. IF CONSCIOUS GIVE WATER,
MILK/MILK OF MAGNESIA. SKIN/EYES: FLUSH W/PLENTY OF WATER FOR 15
MINS. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE APPROPRIATE MEDIA FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR PROPER PROTECTIVE EQUIPMENT & SELF
CONTAINED BREATHING APPARATUS W/FULL FACEPIECE OPERATED IN POSITIVE
PRESSURE MODE.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR SCBA & FULL PROTECTIVE CLOTHING. STOP
LEAK IF POSSIBLE W/OUT RISK. USE WATER SPRAY TO REDUCE VAPORS. TAKE
UP W/SAND/OTHER NON-COMBUSTIBLE ABSORBENT MATERIAL & PLACE INTO
CONTAINER FOR LATER DISPO SAL. FLUSH AREA W/WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED. STORE
IN CORROSION-PROOF AREA.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED.
Ventilation:LOCAL EXHAUST/VENT HOOD.
Other Protective Equipment:LAB COAT
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING & SHOES
BEFORE REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F
Spec Gravity:1
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR COLORLESS SOLUTION W/NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ORGANIC MATERIALS, STRONG REDUCING AGENTS.
Hazardous Decomposition Products:OXIDES OF NITROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
ENVIRONMENTAL REGULATIONS. CORROSIVE WASTE D002.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SUL-FURY
CAGE:OOO55
CAGE:59972
CAGE:OOO55
============= Composition/Information on Ingredients =============
Ingred Name:SULFURIC ACID
IC=INTENDED CHANGES
CAS:7664-93-9
RTECS #:WS5600000
Fraction by Wt: 93%
OSHA PEL:1 MG/CUM
ACGIH TLV:1 MG/CUM=IC
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN/EYES: TISSUE /BURNS INHALATION:
RESPIRATOTY IRRITATION. INGESTION: FATAL.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SKIN/EYES: TISSUE BURNS. INHALATION:
RESPIRATORY IRRITATION. INGESTION: FATAL.
======================= First Aid Measures =======================
First Aid:SKIN/EYES: FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MINUTES.
INHALATION: MOVE TO FRESH AIR. INGESTION: DRINK PLENTY OF WATER A&
DRINK A TEASPOONFUL OR MORE OR MILK OF MAGNESIA, BAKING SODA, OR
SMALL PI ECES OF SOAP SOFTENED W/WATER, IN MILK OR RAW EGG WHITES.
OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:DRY CHEMICAL
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING
Unusual Fire/Explosion Hazard:ACID REACTS W/MOST METALS TO GIVE
FLAMMABLE HYDROGEN GAS.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR FULL PROTECTIVE CLOTHING. REMOVE SOURCES
OF IGNITION. FLUSH AWAY BY FLOODING W/WATER APPLIED QUICKLY TO
ENTIRE AREA. NEUTRALIZE WASHINGS W/LIME OR SODA ASH & FLUSH TO
CHEMICAL SEWER. DON'T POUR W ATER INTO SULFURIC.
Neutralizing Agent:LIME OR SODA ASH
======================Handling and Storage ======================
Handling and Storage Precautions:PROTECT AGAINST PHYSICAL DAMAGE &
WATER.
Other Precautions:REACTS VIOLENTLY W/WATER ACCOMPANIED BY EVOLUTION OF
HEAT SULFRUIC ACID ATTACKS MANY METALS RELEASING FLAMMABLE HYDROGEN
GAS.
============= Exposure Controls/Personal Protection =============
Ventilation:ADEQUATE
Work Hygienic Practices:REMOVE CONTAMINATED CLOTHING & SHOES.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:535F
Vapor Pres:0.001
Spec Gravity:1.835
pH:<1
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS TO BROWNISH OILY LIQUID W/NO ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:NO
CYANIDES/SULFIDES/OR ANY OTHER DRAIN CLEANER & WATER
Hazardous Decomposition Products:HYDROGEN GAS
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:GLASS CLEANER, ANTI-FOGGING TYPE 2
CAGE:6R971
CAGE:6R971
============= Composition/Information on Ingredients =============
Ingred Name:NO INGREDIENT FOR THIS FORMULATION_INGREDIENT
===================== Hazards Identification =====================
Effects of Overexposure:NONE
======================= First Aid Measures =======================
First Aid:NONE
===================== Fire Fighting Measures =====================
Flash Point:130 F CC 54 C
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH W/WATER
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT INGEST-REPLACE LID-STORE IN A
COOL PLACE
Other Precautions:NONE REQUIRED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED
Other Protective Equipment:NONE
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:212 F 100 C
Spec Gravity:1
Solubility in Water:COMPLETE
Appearance and Odor:SLIGHT I.P.A. ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:DILUTE W/WATER-FLUSH DOWN DRAIN.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:METADI AEROSOL SPRAY,40-6268
Preparer's Name:THOMAS R. DERAM
CAGE:09410
CAGE:09410
============= Composition/Information on Ingredients =============
Ingred Name:HEXYLENE GLYCOL
CAS:107-41-5
RTECS #:SA0810000
Fraction by Wt: <10%
OSHA PEL:C 25 PPM
ACGIH TLV:C 25 PPM; 9192
Ingred Name:ISOPROPYL ALCOHOL (SARA III)
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 10-30%
OSHA PEL:400 PPM/500 STEL
ACGIH TLV:400 PPM/500STEL;9192
Ingred Name:FLUORO CHLORO CARBON PROPELLANT(CONSISTING OF INGREDIENTS 4
& 5 AT A 50/50 MIXTURE)
Fraction by Wt: >60%
Other REC Limits:1000 PPM (MFR)
Ingred Name:P-11
CAS:1175-69-4
Ingred Name:DICHLORODIFLUOROMETHANE (SARA III)
CAS:75-71-8
RTECS #:PA8200000
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ozone Depleting Chemical:1
Ingred Name:DIAMOND ABRASIVE VARIOUS GRADES
Fraction by Wt: 5%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:DEFATTING W/PROLONGED CONTACT. SEE
SIGNS AND SYMPTOMS OF EXPOSURE
Effects of Overexposure:EYES/SKIN:MILD IRRITATION.
INHAL:DROWINESS,DIZZINESS,NASAL & RESPIRATORY IRRIT.
INJEST:NAUSEA,VOMIT,DIARR,ABDOM IRRIT.
Medical Cond Aggravated by Exposure:OVEREXPOSURE MAY AGGRAVATE
ASTHMATIC CONDITIONS.
======================= First Aid Measures =======================
First Aid:SKIN: WASH THOROUGHLY W/ SOAP & WATER. INHAL:MOVE INDIVIUAL
TO FRESH AIR.SUPPORT BREATHING (GIVE O*2 ARTF/RESP) . EYES:FLUSH
THOROUGHLY WITH WATER FOR AT LEAST 15 MINUTES. INJEST:DILUTE
W/WATER, INDUCE VOMITING
===================== Fire Fighting Measures =====================
Flash Point:COMBUSTIBLE
Extinguishing Media:WATER,CARBON DIOXIDE,FOAM
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED PRESSURE DEMAND SCBA &
FULL PROTECTIVE EQUIP
Unusual Fire/Explosion Hazard:CONTR CONTAINS LIQ COMPRESSED GAS UNDER
PRESS , PLUS MINOR AMOUNT OF FLAM SOLV. THERM DECOMP PRODUCTS WILL
INCL CHLORIDES, FLUORIDES, PHOSGENE
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA- ABSORB LIQUID ON SUITABLE
INERT ABSORBING MATERIAL AND DISPOSE IN SUITABLE WASTE CONTAINER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:PRODUCT CONTAINS LIQUIFIED GAS UNDER
PRESSURE. AVOID TEMPS ABOVE 125F.
Other Precautions:DO NOT SPRAY NEAR EYES. NO SMOKING IN AREA OF USE.DO
NOT USE IN GENERAL VICINITY OF ARC WELDING, OPEN FLAMES OR HOT
SURFACES. HEAT &/OR UV RADIATION MAY CAUSE FORMATION OF CHLORIDES,
FLUORIDES OR PHOS GENE .
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED AIR MASK IN PRESENCE OF
HIGH VAPOR CONCENTRATION.
Ventilation:LOCAL EXHAUST TO MAINTAIN EXPOSURE BELOW TLV LIMITS
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:GOOD PERSONAL HYGIENE TO BE FOLLOWED AT ALL
TIMES.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:-6F,-21C
Melt/Freeze Pt:M.P/F.P Text:90%
Vapor Pres:1900@70F
Vapor Density:3
Spec Gravity:<1
Evaporation Rate & Reference:<1(BUTYL ACEETATE=1)
Solubility in Water:PARTIALLY SOLUBLE
Appearance and Odor:PLEASANT ODOR,VARIOUS COLORS ACCORDING TO DIAMOND
GRADE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT W/STRONG MINERAL ACIDS, STRONG OXIDIZING AGENTS,RUBBER
AND SOME PLASTICS.
Stability Condition to Avoid:OPEN FLAMES OR HIGH TEMPS ABOVE 125F IN
STORAGE CANS.
Hazardous Decomposition Products:HIGH TEMPERATURES (FLAME) DECOMP OF
PROPELLANT ONLY MAY FORM HYDROCHLORIC AND HYDROFLUORIC
ACIDS,POSSIBLY PHOSGENE.
==================== Disposal Considerations ====================
Waste Disposal Methods:FLUSH WASTE MATERIAL WITHOUT PROPELLANT DOWN
DRAIN
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:08605GUZ-GD 383 GREEN ZENTHANE, MIL-C-53039A
Preparer's Name:JANE FREEMAN
CAGE:09225
CAGE:09225
============= Composition/Information on Ingredients =============
Ingred Name:METHYL ISOAMYL KETONE SOLVENT
CAS:110-12-3
RTECS #:MP3850000
Fraction by Wt: 20.516%
Other REC Limits:NONE SPECIFIED
OSHA PEL:50 PPM
ACGIH TLV:50 PPM
Ingred Name:SILICA PIGMENT (SARA 313)
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 20-30%
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.1 MG/M3
ACGIH TLV:0.1 MG/M3
Ingred Name:HOMOPOLYMER OF HEXAMETHYLENE DIISOCYANATE (HDI)(EXACT
PERCENTAGE IS A TRADE SECRET)
CAS:28182-81-2
RTECS #:HQ9170000
Fraction by Wt: 20-30%
Other REC Limits:MFR.5MG.M3STEL1MG/M3
Ingred Name:AROMATIC HYDROCARBONS (MIXTURE OF C8'S TO C10'S)
CAS:64742-95-6
Fraction by Wt: 1.497%
Other REC Limits:100 PPM = MFR'S
Ingred Name:BUTYL ACETATE SOLVENT
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: 1.194%
Other REC Limits:NONE SPECIFIED
OSHA PEL:150 PPM/STEL 200 PPM
ACGIH TLV:150 PPM/STEL 200 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:HEXAMETHYLENE DIISOCYANATE MONOMER (SARA 313)
CAS:822-06-0
RTECS #:MO1740000
Fraction by Wt: 0.047%
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.005 PPM
ACGIH TLV:0.005 PPM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:VM&P NAPHTHA SOLVENT
CAS:8030-30-6
RTECS #:DE3030000
Fraction by Wt: 4.795%
Other REC Limits:NONE SPECIFIED
OSHA PEL:300 PPM
ACGIH TLV:300 PPM
Ingred Name:XYLENE (SARA 313)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 4.875%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM/STEL 150 PPM
ACGIH TLV:100 PPM/STEL 150 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:VOC: 3.497 LBS/GAL; 419.045 GRAMS/LITER
RTECS #:9999999VO
Other REC Limits:NONE SPECIFIED
Ingred Name:MAGNESIUM FERRITE PIGMENT
CAS:12068-86-9
Fraction by Wt: 1-5%
Other REC Limits:NUISANCE DUST
OSHA PEL:10 MG/M3
ACGIH TLV:15 MG/M3
Ingred Name:COBALT COMPOUNDS (AS CO)(SARA 313)
CAS:7440-48-4
RTECS #:GF8750000
Fraction by Wt: 0.429%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.05 MG/M3
ACGIH TLV:0.05 MG/M3
Ingred Name:TRIVALENT CHROME (INSULUBLE)(SARA 313)
CAS:7440-47-3
RTECS #:GB4200000
Fraction by Wt: 6.997%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.5 MG/M3
ACGIH TLV:0.5 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:OXIDE PORTION OF CHROME OXIDE
CAS:1317-38-9
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CHRONIC: OVEREXPO TO SOLVENTS CAUSE
PERMANENT BRAIN/NERVOUS SYSTEM/LIVER/KIDNEY DAMAGE. OVEREXPO TO
ISOCYANATE LEADS TO RESPIRATORY SENSITIZATION CHARACTERIZED BY
ALLERGIC DERMATITIS WHICH INCLUDES RA SH, ITCHING, HIVES, SWELLING.
INGEST: IRRIT/CORROSIVE TO MOUTH/STOMAH TISSUE/DIGEST TRACT/SORE
THROAT** TRIVALENT ****
Explanation of Carcinogenicity:BASED UPON LABORATORY ANIMAL DATA, IARC
HAS LISTED SILICA AS A "PROBABLE HUMAN CARCINOGEN."
Effects of Overexposure:SKIN/EYE/RESP TRACT IRRIT (NOSE/THROAT/LUNGS).
WATERING EYES/DRY THROAT/COUGHING/HEADACHE/TIGHT CHEST/BURNING
SENSATION. SOLVENTS EXPOSURE MAY CAUSE HEADACHE/DIZZINESS/NAUSEA.
SHORTNESS OF BREATH. EXP OSURE >LIMITS MAY LEAD TO
BRONCHITIS/BRONCHIAL SPASM/PULMINARY EDEMA. CHEM/HYPERSENSITIVE
PNEUMONITIS W/FLU-LIKE SYMPTOM
Medical Cond Aggravated by Exposure:SKIN ALLERGIES AND EXEMA, ASTHMA &
OTHER RESPIRATORY AILMENTS, CHEMICAL SENSITIZATION. **** CHROME
EXPOSURE MAY CAUSE DELAYED RESP SYSTEM EFFECTS/DERMATITIS
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. CONSULT
DR. EYES: FLUSH IMMED W/LUKE WARM RUNNING WATER 15 MINUTES, LIFTING
EYELIDS. GET MEDICAL ATTENTION. SKIN: REMOVE CONTAM CLOTHES/WASH
BEFORE REUSE. USE SAFETY SHOWER AFTER REMOVINGCLOTHES. GET MEDICAL
AID. LESSER EXPOSURE, CONTACT DR IF IRRITATION DEVELOPS/PERSISTS.
INGESTION: CALL DR IMMED. DON'T INDUCE VOMITING.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:54.0F,12.2C
Autoignition Temp:Autoignition Temp Text:450F
Lower Limits:0.9
Upper Limits:8.2
Extinguishing Media:CO2, DRY CHEMICAL, FOAM, ALCOHOL FOAM.
Fire Fighting Procedures:FULL PROTECTIVE EQUIPMENT W/SCBA SHOULD BE
WORN. DURING A FIRE, IRRITATING & HIGHLY TOXIC GASES & SMOKE ARE
PRESENT FROM THE DECOMPOSITION/COMBUSTION PRODUCTS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS EXPOSED TO EXTREME HEAT
MAY EXPLODE OR BURST WHEN CONTAMINATED W/H20 (CO2 RELEASED). DON'T
WELD, CUT, TORCH DRUMFULL/EMPTY MAY IGNITE/EXPLODE.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE NON-ESSENTIAL PERSONNEL. REMOVE IGNIT
SOURCES (FLAMES/HOT SURFACES/ELECTRICAL/STATIC/SPARKS). VENTILATE
AREA.AVOID BREATHING VAPORS. COVER W/INERT ABSORBENT.POUR
DECONTAMINANT/ALLOW TO REACT >10 MIN.COLLECT IN OPEN CNTNR/ADD
MORE DECONTAM***
Neutralizing Agent:3-8% CONCENTRAT AMMONIA/2% DETERGENT/90-95% H2O OR
TERGITOL TNN-10 20%/WATER 80%
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T STORE >120F OR <32F. STORE LRG
QUANTITIES IN BUILDINGS DESIGNED TO COMPLY W/OSHA 1910.106. KEEP
AWAY FROM ALL HEAT. KEEP TIGHTLY CLOSED.
Other Precautions:DON'T INGEST. GROUND WHEN POURING. AVOID POURING
LIQUID IN EXCESS OF FEW INCHES. VENTILATE, USE PROPER RESP EQUIP.
EMPTY CNTNRS RETAIN HAZARDOUS RESIDUE/EXPLOSIVE VAPORS. PROTECT
FROM MOISTURE, IF MOI STURE ENTERS PRESSURE CAN BUILD UP.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:THE SURGEON GENERAL REQUIRES AIRLINE RESPIRATORS
USED UNLESS AIR SAMPLING SHOWS EXPOSURE BELOW OSHA LIMITS. THEN
EITHER, CHEMICAL CARTRIDGE RESPIRATORS OR AIRLINE RESPIRATORS.
Ventilation:GENERAL DILUTION VENTILATION, LOCAL EXHAUST VENTILATION TO
KEEP AIR CONTAMINANT CONCENTRATION BELOW OSHA REQUIREMENTS.
Other Protective Equipment:WEAR PROTECTIVE CLOTHING TO KEEP SKIN
CONTACT AT A MINIMUM.
Work Hygienic Practices:REMOVE & WASH CONTAMINATED CLOTHING BEFORE
REUSE. WASH THOROUGHLY AFTER HANDLING & BEFORE EATING OR SMOKING.
Supplemental Safety and Health
SMOKE IN DESIGNATED AREAS ONLY. **CAUSING ABDOMINAL PAIN, NAUSEA,
VOMITING, DIARRHEA. CHRONIC OVEREXPOSURE CAN CAUSE LUNG DAMAGE.
(NOTE: MORE INFO ON FILE). ***SOLUTION. REMOVE CONTAINERS TO SAFE
PLACE, COVER LOOSELY. ALLOW TO STAND FOR 24 TO 48 HOURS. PREVENT
ENTRY INTO DRAINS/SEWERS/WATERWAYS. NOTIFY AUTHORITIES.
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:244F,118C
Melt/Freeze Pt:M.P/F.P Text:NA
Vapor Pres:15.0
Vapor Density:> AIR
Spec Gravity:1.23
Viscosity:65-68 KU
Evaporation Rate & Reference:FASTER THAN BUTYL ACETATE
Solubility in Water:REACTS WITH WATER
Appearance and Odor:OPAQUE LIQUID WITH SOLVENT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
EPOXY CATALYSTS, ALCOHOLS, GLYCOL ETHERS, BASES, METAL COMPLEXES OR
OTHER ACTIVE MATERIALS.
Stability Condition to Avoid:CONTAMINATION W/H20. ONCE MATERIAL HAS
BEEN EXPOSED TO ANY OF THE BELOW OR ATMOSPHERIC MOISTURE, DON'T
SEAL CONTAINER*
Hazardous Decomposition Products:BY FIRE: CO2, CO, OXIDES OF NITROGEN,
TRACES OF HYDROGEN CYANIDE, HEXAMETHYLENE DIISOCYANATE, CHLORINE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF ACCORDING TO GOVERNMENT REGS.
DECONTAMINATE CONTAINERS BEFORE DISPOSAL.
======================================================================
| 1 | gloves_mandatory |
=======================================================
Product ID: NIPOL AR 31
Cage: 0J3F9
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: ZEXNG
Box: UNKNOW
Cage: 0J3F9
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE: NO ADVERSE HLTH EFTS EXPECTED DURING NORM
PROCESSING WHEN POTENTIAL EXPOS ARE ELIMINATED BY GOOD INDUS HYGIENE PRACT
& WELL VENTD CNDTNS. AT PROCESSING TEMPS, COMBINED INGS (ELASTOMER &
OTHER P ROCESSING INGS) MAY EMIT FUMES & VAPS THAT MAY CAUSE IRRIT TO
EYES, SKIN, NOSE, THROAT, & RESP TRACT. PROCESSING UNDER CNDTNS OF INADEQ
VENT MAY PRDCE SYMPS OF NAUS, DIZZ/HDCH. TYPICALLY THESE EFTS AR E REVERSIBLE
UPON REMOVAL FROM EXPOS & NO LASTING EFTS ARE EXPECTED. MOST IMPORTANTLY,
POTENTIAL FOR IRRIT WILL DEPEND ON EFFECTIVENESS OF EXHST VENT PROVIDED TO
PROCESS AREA. ALTHOUGH RARE, THERE ARE RPTS OF (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: HLTH HAZ:DEPIGMENTATION OF SKIN (VITILIGO)
ASSOC W/P-T-BUTYL PHENOL IN RELATED ELASTOMER PRODS. MFR RECS THAT CONT
FOR HNDLG & /OR PROCESSING OPERATIONS. OVEREXP TO DECOMP/COMBUST PRODS
MAY CAUSE IRRIT OF EYES, SKIN & RESP TRACT. REGARD SYMPS AS COUGH,
TEARING, & IRRIT AS POTENTIAL HAZ & TAKE MEASURES TO AVOID EXPOS.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: IF IRRIT OCCURS/PERSISTS FROM ANY RTE OF EXPOS, REMOVE FROM AREA
& SEEK MED ASSIST. EYE: FLUSH W/RUNNING WATER FOR AT LEAST 15 MIN WHILE
HOLDING EYELIDS OPEN. CONSULT MD IF IRRIT PERSISTS. SKIN: REMOV E CONTAM
CLTHG. WASH SKIN W/SOAP & WATER FOR 15 MIN. INHAL: REMOVE TO FRESH AIR.
IF BRTHG STOPPED, ADMIN ARTF RESP & SEEK MED ASSIST IMMED. INGEST: CALL
MD IMMED (FP N).
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: SWEEP, SHOVEL, OR VACUUM CRUMBS OR CHUNKS INTO CLOSED
CONTAINERS FOR REUSE OR DISPOSAL.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: AS SUPPLIED, THESE PRODUCTS ARE NOT DEFINED OR
DESIGNATED AS HAZARDOUS BY CURRENT PROVISIONS OF THE FEDERAL (EPA) RCRA (40
CFR 261). LANDFILL OR INCINERATION IN ACCORDANCE WITH FEDERAL, STATE, AND LOC
AL REGULATIONS.
Handling And Storage Precautions: DURING NORMAL PROCESSING, VIRTUALLY ALL
ELASTOMERS WILL EMIT FUMES AND VAPORS WHEN HEATED TO PROCESSING TEMPERATURES.
Other Precautions: CONC & COMPOSITION OF THESE VAPS WILL DEPEND ON
VARIABLES SUCH AS SPECIFIC FORMULATION & PROCESSING METH & TEMP.
ALWAYS PROCESS ELASTOMERS UNDER WELL VENTD CNDTNS & AVOID CONTINUED/PRLNG
BRTHG OF PROC ESS VAP. DO NOT USE/CONSUME FOOD IN PROCESSING AREA. DO NOT USE
PROCESSING EQUIP TO HEAT FOOD. CLEANUP (SUPDAT)
=======================================================
Fire and Explosion Hazard Information
=======================================================
Extinguishing Media: WATER, ABC DRY CHEM/PROTEIN TYPE AIR FOAMS REC. ELASTOMERS
WOULD BE CONSIDERED "ORDINARY COMBUSTS" (NFPA CLASS A). CARBON DIOXIDE GEN
NOT REC FOR USE ON CLASS A FIRE AS LACK (SUPDAT)
Fire Fighting Procedures: WEAR NIOSH APPRVD SCBA & FULL PROT EQUIP (FP N).
PERS NOT HAVING SUITABLE RESP PROT MUST LEAVE AREA TO PVNT SIGNIFICANT EXPOS
TO TOX COMBUST GASES.
Unusual Fire/Explosion Hazard: SPECIAL PREC MUST BE TAKEN IF ELASTOMERS ARE
GROUND/OTHERWISE FORMED INTO FINE POWDER/DUST SINCE MANY ORG SUBSTANCES IN
THESE FORMS PRESENT DUST EXPLO HAZ. TOX GASES MAY BE FORMED UPON COMBUST
& REPRE SENTS HAZ TO FIREFIGHTERS.
=======================================================
Control Measures
=======================================================
Respiratory Protection: RESP PROT MAY BE NEEDED IF VAP/DUST IS GENERATED DURING
PROCESSING/IF PROD IS GROUND INTO FINE POWDER. WEAR NIOSH APPRVD POS PRESS
AIR-SUPP RESP WHEN POTENTIAL FOR ELEVATED AIRBORNE EXPOS SUCH AS DURI NG
EQUIP MALFUNCTION, OR PRODUCT HANGUP OR STAGNATION DURING PROCESSING THAT MAY
RESULT IN DECOMPOSITION.
Ventilation: ALWAYS PROVIDE LOCAL EXHAUST. VENTILATION MUST BE ADEQUATE TO
MAINTAIN AMBIENT WORKPLACE ATMOSPHERE BELOW LIMITS.
Other Protective Equipment: EMERGENCY EYEWASH AND DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA (FP N).
Work Hygienic Practices: WASH THOROUGHLY AFTER PROCESSING, ESPECIALLY BEFORE
EATING, SMOKING, OR USING TOILET FACILITIES.
Supplemental Safety and Health: USERS OF "L" VERSION OF SHOULD CONSULT "LR"
VERSION FOR ADDNL INFO (FP N). EXTING MEDIA: OF COOLING CAPACITY MAY RSLT IN
REIGNIT. OTHER PREC: FOLLOWING NORM PROCESSING SHOULD BE PERFORMED UNDER W
ELL-VENTD CNDTNS. ELASTOMER MAY BE HELD AT PROCESS TEMPS FOR SHORT TIME W/OUT
SIGNIFICANT DEGRADATION. (OTHER INFO)
=======================================================
Physical/Chemical Properties
=======================================================
Spec Gravity: 1.0 (H*2O=1)
Solubility in Water: INSOLUBLE
Appearance and Odor: OFF-WHITE COLORED SLAB; MILD CHARACTERISTIC ACRYLIC ODOR
Percent Volatiles by Volume: <1(WT)
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: OVERHEATING.
Materials To Avoid: STRONG OXIDIZERS/REDUCING AGENTS WHICH ARE GENERALLY NOT
COMPATIBLE W/MANY ORG CMPDS, ARE NOT COMPATIBLE W/ELASTOMERS.
Hazardous Decomposition Products: FUMES PRDCED WHEN HEATED TO DECOMP TEMPS MAY
CONTAIN CARBON MONOXIDE & DIOXIDE, HYDROGEN CYANIDE, & SML AMTS OF AROMATIC &
ALIPHATIC HYDROCARBS. COMBUST PRODS FROM RUBBER, LIKE THOSE OF OTHER (TOX
INFO)
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
Toxicological Information: OTHER INFO: PRESS SCBA. COMPOUNDING INGS ADDED TO
ELASTOMER PRODS MAY REQUIRE SPECIAL HNDLG. IT IS USERS RESPONSIBILITY TO
FOLLOW REC PREC OF INDIV ADDITIVE SUPPLIERS. POST-PROCESSING OPERATIONS AT Y
OUR WORKPLACE/AT YOUR CUSTOMER'S WORKPLACE INVOLVING HEAT SUFFICIENT TO RSLT
IN POLYMER BREAKDOWN EMITTING SMOKE & FUMES SHOULD ALWAYS BE CONDUCTED IN
SUCH MANNER TO AVOID INHAL OF FUMES. LOCAL EXHA UST VENT SHOULD BE PROVIDED
TO PREVENT SIGNIFICANT EMPLOYEE EXPOSURE. HAZ DECOMP PROD: AROMATIC &
ALIPHATIC HYDROCARBONS. COMBUST PRODS FROM RUBBER, LIKE THOSE OF OTHER
NATURAL AND SYNTHETIC MATERIALS , MUST BE CONSIDERED TOXIC.
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
Other Information: OTHER PREC: HOWEVER EXPOS TO EITHER ELEVATED TEMP/EXCESS
TIME WILL RSLT IN DECOMP. EQUIP SHOULD NOT BE SHUT DOWN FOR EXTENDED TIME
PERIODS W/CMPD IN IT/DECOMP MAY OCCUR. PROCESSING FUME CONDENSATES, W HICH
MAY INCL TOX CONTAMS, MAY BE COMBUST & SHOULD BE PERIODICALLY REMOVED
FROM EXHST HOODS, DUCTWORK, & OTHER SURFS. STORE IN COOL, DRY PLACE AWAY
FROM DIRECT LIGHT TO MAINTAIN QUALITY. ABNORM CNDTNSSUCH AS EQUIP
MALFUNC/USING IMPROPER EQUIP/PROC, OR HANGUP/STAGNATION OF MATL DURING
PROCESSING MAY CAUSE DECOMP. EMPLOYEES INVOLVED IN REMOVING DECOMP MATL
SHOULD BE PROVIDED SUITABLE AIR-SUPP RESPS , SUCH AS NIOSH APPRVD POS (TOX
INFO)
=======================================================
HAZCOM Label
=======================================================
Product ID: NIPOL AR 31
Cage: 0J3F9
Company Name: ZEON CHEMICALS L.P.
Street: 4111 BELLS LANE
Zipcode: 40211
Label Required IND: Y
Date Of Label Review: 03/11/1998
Status Code: C
Label Date: 03/11/1998
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Slight
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: ACUTE: NO ADVERSE HEALTH EFFECTS EXPECTED DURING NORMAL
PROCESSING WHEN POTENTIAL EXPOSURES ARE ELIMINATED BY GOOD INDUSTRIAL HYGIENE
PRACTICE AND WELL VENTILATED CONDITIONS. AT PROCESSING TEMPERATURE S,
COMBINED INGREDIENTS (ELASTOMER AND OTHER PROCESSING INGREDIENTS) MAY EMIT
FUMES AND VAPORS THAT MAY CAUSE IRRITATION TO EYES, SKIN, NOSE, THROAT, AND
RESPIRATORY TRACT. PROCESSING UNDER INADEQUATE VENTILATION CONDITIONS MAY
PRODUCE NAUSEA, DIZZINESS OR HEADACHES WHICH TYPICALLY CEASE UPON REMOVAL
FROM EXPOSURE WITH NO LASTING EFFECTS. CHRONIC: CONTAINS TRACE AMOUNTS OF
MATERIALS LISTED AS CARC INOGENS.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:P4 ECONOLINE FILMS
CAGE:61263
CAGE:61263
============= Composition/Information on Ingredients =============
Ingred Name:SILVER CHLORIDE
CAS:9007-35-6
RTECS #:VW3675000
ACGIH TLV:10 MG/CUM
Ingred Name:SILVER BROMIDE
CAS:7785-23-1
ACGIH TLV:10 MG/CUM
Ingred Name:GELATIN, GELATINE
CAS:9000-70-0
RTECS #:LX8580000
Ingred Name:CADMIUM CHLORIDE (SARA III)
CAS:10108-64-2
RTECS #:EV0175000
Fraction by Wt: TRACE
OSHA PEL:SEE 1910.1027
ACGIH TLV:0.05 MG(CD)/M3; 9293
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:POLYESTER
Fraction by Wt: >90%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:SKIN: THIS PRODUCT CONTAINS SMALL
AMOUNTS OF A CADIUM SALT & MAY CAUSE LOCALIZED IRRITATION.
Explanation of Carcinogenicity:CADMIUM IS A SUSPECTED 2B CARCINOGEN.
Effects of Overexposure:SKIN: THIS PRODUCT CONTAINS SMALL AMOUNTS OF A
CADMIUM SALT & MAY CAUSE LOCALIZED IRRITATION.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE FROM SOURCE OF EXPOSURE. SKIN: WASH
THOROUGHLY W/WATER. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WATER MIST, ALCOHOL FOAM, CO2, OR DRY CHEMICAL
================== Accidental Release Measures ==================
Spill Release Procedures:UNEXPOSED FILM SHEETS MAY BE REPACKAGED FOR
FUTURE USE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE AWAY FROM
HEAT, RADIATION OR LIGHT SOURCES. DON'T IMMERSE INTO WATER OR
CHEMICALS PRIOR TO PROCESSING.
Other Precautions:AVOID EXPOSURE TO SOLUTIONS & INHALATION OF
COMBUSTION FUMES.
============= Exposure Controls/Personal Protection =============
Work Hygienic Practices:WASH HANDS AFTER HANDLING FILM/FOLLOWING
EXPOSURE TO FILM PROCESSING SOLUTIONS.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Vapor Pres:NEGLIGIBLE
Vapor Density:NEGLIGIBLE
Evaporation Rate & Reference:(BU AC = 1): NEGLIGIBLE
Solubility in Water:INSOLUBLE
Appearance and Odor:GREY EMULSION COATED FILM W/NO DISTINGUISHING ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HEAT, LIGHT & OTHER RADIATION SOURCES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL OF FILM & FILM PROCESSING SOLUTIONS
SHOULD BE MADE IN CONFORMANCE W/APPLICABLE LOCAL, STATE & FEDERAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:HI I HEAT CURE MONOMER POLYMER
CAGE:UO045
CAGE:UO045
============= Composition/Information on Ingredients =============
Ingred Name:DIALKYL PHTHALATE
< Wt:5.
ACGIH TLV:5 MPM
Ingred Name:CADMIUM SULFOSELENIDE
CAS:12656-57-4
< Wt:.1
ACGIH TLV:0.05 MGM
===================== Hazards Identification =====================
Health Hazards Acute and Chronic:INGESTION OF SMALL QUANTITIES OF THIS
MATERIAL UNDER NORMAL CIRCUMSTANCES WOULD NOT CAUSE HARMFUL
EFFECTS. INHALATION: GROSS OVEREXPOSURE TO NUISANCE PARTICLES,
REGARDLESS OF HOW GENERATED, MAY CAUSE IRRITATION OF THE
RESPIRATORY TRACT. SKIN OR EYE CONTACT: NUISANCE PARTICLES MAY
CAUSE IRRITATION.
Medical Cond Aggravated by Exposure:
======================= First Aid Measures =======================
First Aid:SKIN: WASH WITH SOAP AND WATER. INHALATION: REMOVE TO FRESH
AIR. APPLY CPR IF NECESSARY. EYE: FLUSH W/ WATER FOR 15 MINS. IF
IRRITATION PERSISTS, CONTACT A PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:=304.4C, 580.F
Extinguishing Media:DRY CHEMICAL, CARBON DIOXIDE, WATER
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP CAREFULLY TO PREVENT SLIPPING HAZARD.
======================Handling and Storage ======================
Handling and Storage Precautions:DRY STORAGE CONTAINERS CLOSED TO
PREVENT MOISTURE ABSORPTION AND CONTAMINATION.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED UNDER NORMAL PROCESSING
CONDITIONS.
Ventilation:LOCAL EXHAUST AT PROCESSING EQUIPMENT. HIGH TEMPERATURES
PROCESSING EQUIPMENT SHOULD BE WELL VENTILATED.
Other Protective Equipment:NONE
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Evaporation Rate & Reference:NIL
Solubility in Water:NIL
Percent Volatiles by Volume:LESS THAN 5
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS AND OXIDIZING AGENTS
Stability Condition to Avoid:TEMPERATURES ABOVE 580F
Hazardous Decomposition Products:METHYK METHACRLATE AND CARBON MONOXIDE
DEPENDING ON CONDITIONS OF HEATING OR BURNING.
=================== Toxicological Information===================
Toxicological Information:EPIDEMIOLOGY: NO INFORMATION FOUND.
TERATOGENICITY: NO INFORMATION FOUND. REPRODUCTIVE EFFECTS: NO
INFORMATION FOUND. NEUROTOXICITY: NO INFORMATION FOUND.
MUTAGENICITY: NO INFORMATION FOUND. OTHER STU DIES: SEE ACTUAL
ENTRY IN RTECS FOR COMPLETE INFORMATION.
===================== Ecological Information =====================
Ecological:ECOTOXICITY: NOT AVAILABLE. ENVIRONMENTAL FATE: NOT
AVAILABLE. PHYSICAL/CHEMICAL: NOT AVAILABLE. OTHER: NOT AVAILABLE.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATION OR LANDFILL. COMPLETE COMBUSTION IN
AIR GIVES WATER AND CARBON DIOXIDE
=================== MSDS Transport Information ===================
Transport Information:US DOT: SHIPPING NAME: SODIUM HYDROXIDE,
SOLUTION. HAZARD CLASS: 8. UN NUMBER: UN1824. PACKING GROUP: II.
CANADIAN TDG: SHIPPING NAME: SODIUM HYDROXIDE, SOLUTION. HAZARD
CLASS: 8 (9.2). UN NUMBER: UN1 824.
===================== Regulatory Information =====================
SARA Title III Information:SECTION 302 (RQ): CAS# 1310-73-2, FINAL RQ:
1000 LBS 9454 KG). SECTION 302 (TPQ): NONE OF THE CHEMICALS IN THIS
PRODUCT HAVE A TPQ. SARA CODES: 1310-73-2, ACUTE, REACTIVE. SECTION
313: NO CHEMICALS AR E REPORTABLE UNDER SECTION 313.
Federal Regulatory Information:TSCA: CAS 1310-73-2 IS LISTED ON THE
TSCA INVENTORY. CAS 7732-18-5 IS LISTED ON THE TSCA INVENTORY.
CHEMICAL TEST RULES: NONE OF THE CHEMICALS IN THIS PRODUCT ARE
UNDER A CHEMICAL TEST RULE. HEALTH & SAFETY REPORTING LIST: NONE
OF THE CHEMICALS IN THIS PRODUCT ARE ON THE HEALTH & SAFETY
REPORTING LIST. SECTION 12B: NONE OF THE CHEMICALS IN THIS PRODUCT
ARE LISTED UNDER 12B. TSCA SIGNIFIGANT NEW US E RULE: NONE OF THE
CHEMICALS IN THIS PRODUCT HAVE A SNUR UNDER TSCA. CLEAN AIR ACT:
THIS PRODUCT DO ES NOT CONTAIN ANY HAZARDOUS AIR POLLUTANTS, CLASS
1 0R 2 OZONE DEPLETORS.
State Regulatory Information:SODIUM HYDROXIDE CAN BE FOUND ON THE
FOLLOWING STATE RIGHT TO KNOW LISTS: CALIFORNIA, NEW JERSEY,
FLORIDA, PENNSYLVANIA, MINNESOTA, MASSACHUSETTS. CALIFORNIA NO
SIGNIFIGANT REISK LEVEL: NONE OF THE CH EMICALS IN THIS PRODUCT ARE
LISTED.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ACETYLENE, ETHYNE, ETHINE
CAGE:WESTR
CAGE:WESTR
============= Composition/Information on Ingredients =============
Ingred Name:ACETYLENE
CAS:74-86-2
RTECS #:AO9600000
OSHA PEL:N/K
ACGIH TLV:ASPHYXIANT
Ingred Name:SUPDAT:REIGNIT IF FIRE IS EXTING W/OUT SHUTTING OFF
ACETYLENE SOURCE. IGNITES VERY EASILY DUE TO LOW MIN IGNIT (ING 3)
RTECS #:9999999ZZ
Ingred Name:ING 2:ENERGY; VERY WIDE FLAMM LIMS. ACETYLINE GAS HAS
APPROX SPECIFIC GRAVITY OF 1 & TENDS TO STAY IN POCKETS (ING 4)
RTECS #:9999999ZZ
Ingred Name:ING 3:RATHER THAN DISSIPATE.
RTECS #:9999999ZZ
Ingred Name:CNDTNS (STAB):NEVER EXPOSE CYLINDER OR ACETYLENE SYSTEMS TO
SOURCES OF HEAT.
RTECS #:9999999ZZ
Ingred Name:MATLS TO AVOID:POTASSIUM, SILVER & SILVER SALTS & HNO*3.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC:NORMAL ATMOSPHERE. ASSISTED RESPIRATION &
SUPPLEMENTAL OXYGEN SHOULD BE GIVEN IF VICTIM IS NOT BREATHING.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC:EVEN FOR SHORT DIST. USE SUITABLE HAND TRUCK.
STOR OF 2500 CU FT/LESS IS PERMISSIBLE W/IN BLDGS. STOR (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8:IN EXCESS OF 2500 CU FT MUST BE OUTDOORS/IN WELL
VENTED SPECIAL ROOMS/BLDGS. KEEP CYLS AWAY FROM SOURCE OF(ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9:HEAT. STOR SHOULD NOT BE IN HEAVY TRAFFIC AREAS TO
PVNT ACCIDENTAL KNOCKING OVER/DMG FROM PASSING/FALLING (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10:OBJECTS. VALVE CAPS SHOULD REMAIN ON CYLS NOT
CONNECTED FOR USE. SEGREGATE FULL & EMPTY CYLS. KEEP (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11:ACETYLENE CYLS STOR AREAS AWAY FROM STOR OF OXYG &
OTHER OXIDIZERS. STOR AREAS SHOULD BE FREE OF COMBUST (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12:MATL. AVOID EXPOS TO AREAS WHERE SALT/OTHER CORR
CHEMS ARE PRESENT. STORE ACETYLENE CYLS W/VALVE END UP. (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13:FOR ADDNL HNDLG/STOR RECS ON COMPRESSED GAS CYLS,
CONSULT COMPRESSED GAS ASSOC PAMPHLET P-1 & NFPA STD (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14:NO. 51. ACETYLENE CYLS SHOULD BE STORED & USED IN
UPRIGHT POSITION. WHEN USING ACETYLENE, CLOSE CYL VALVE(ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15:BEFORE SHUTTING OFF REGULATOR TO PERMIT GAS TO BLEED
FROM REGULATOR. AVOID HAZ MIXTS & SOURCES OF IGNIT. (ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16:FORM OF EXPLO COPPER ACETYLIDES CAN BE AVOIDED BY
USING COPPER ALLOYS PROVED SUCCESSFUL THRU USE IN (ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17:INDUSTRY. COMPRESSED GAS CYLS SHOULD NOT BE REFILLED
EXCEPT BY QUALIFIED PRDCRS OF COMPRESSED GASES. (ING 19)
RTECS #:9999999ZZ
Ingred Name:ING 18:SHIPMENT OF COMPRESSED GAS CYL FILLED W/OUT
PERMISSION OF OWNER IS A VIOLATION OF FEDERAL LAW.
RTECS #:9999999ZZ
Ingred Name:VENT:CODE REQUIREMENTS FOR CLASS 1, GRP A. MECH
(GEN)/OTHER: AS NECESSARY.
RTECS #:9999999ZZ
& WELDING OPERATIONS.
RTECS #:9999999ZZ
CUTTING & WELDING.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SYMPS SUCH AS HDCHS, DIZZ, SHORTNESS
OF BREATH & LOSS OF CONSCIOUSNESS MAY OCCUR IF GAS IS PRESENT IN
QTYS SUFFICIENT TO DILUTE OXYG CONC IN AIR. SYMPS OF ANOXIA MAY
OCCUR ONLY WHEN GAS CONCS ARE W/INFLAMM RANGE & MIXT HAS NOT
IGNITED. (DO NOT ENTER AREAS W/IN FLAMM RANGE DUE TO IMMED FIRE &
EXPLO (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:HAZ.) USE SUITABLE FLAMM GAS METER
(EXPLOSIMETER) CALIBRATED FOR ACETYLENE TO MEASURE CONCS OF GAS IN
AIR. ACETYLENE IS SIMPLE ASPHY, IRRIT & ANESTH. ABOUT 100 MG/LITER
MAY BE TOLERATED FOR 0 .5-1 HR. THERE IS NO EXPERIMENTAL EVID OF
CHRONIC HARMFUL EFTS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD IMMED . EYES:IMMED FLUSH W/POTABLE WATER FOR
MIN OF 15 MINS, SEEK ASSISTANCE FROM MD . SKIN:FIRST DEGREE & MINOR
SECOND DEGREE THERMAL BURNS FROM FIRES SHOULD BE IMMERSED IN COOL
WATER FOR 30 MINS. MAJOR SECOND &THIRD DEGREE BURNS SHOULD BE
COVERED IN CLEANEST MATL AVAIL. SEEK IMMED AID OF MD. INHAL:PERS
SUFFERING FROM LACK OF OXYG SHOULD BE MOVED TO AREAS W/ (ING 7)
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:0F,-18C
Lower Limits:2.5%
Upper Limits:100%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, HALON.
Fire Fighting Procedures:USE NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP .
STOP GAS FLOW & FIGHT CONVENTIONALLY. USE WATER SPRAY TO KEEP
CYLS/OTHER CNTNRS COOL IF EXPOS TO (SUPDAT)
Unusual Fire/Explosion Hazard:ACETYLENE IS EXTREMELY FLAMM & EXPLO. IT
MAY DECOMP VIOLENTLY IN ITS FREE STATE UNDER PRESS IN EXCESS OF 15
PSIG. IT BURNS W/INTENSELY HOT FLAME. POTNTL(SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA TO PREVENT FLAMM MIXT FROM
FORMING. REMOVE SOURCES OF IGNIT, HEAT, SPARKS, ETC. AVOID ENTERING
AREA OF FLAMM ATM. CAREFULLY REMOVE CYLS W/SLOW LEAKS TO REMOTE,
OUTDOOR LOCATION. CONTACT WESTERN INTERNATIONAL FOR ASSISTANCE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE ONLY IN WELL-VENTILATED AREAS.
ACETYLENE GAS CYLS CONTAIN GAS AT HIGH PRESS & SHOULD BE HNDLD
W/CARE. USE PRESS REDUCING REGULATOR AT <15 PSIG.
Other Precautions:ALWAYS KEEP ACETYLENE CYLS UPRIGHT & SECURE CYLS WHEN
IN USE. NEVER EXPOSE ACETYLENE CYL TO HEAT. ALWAYS OPEN & CLOSE
ACETYLENE VALVES SLOWLY. RETURN CYLS TO MFR W/POS PRESS & CYL VALVE
CLSD. AVOID DR AGGING, ROLLING/SLIDING CYLS, (ING 8)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:NATRL/MECH WHERE GAS IS PRESENT. LOC EXHST/MECH(GEN):AS
NEC. MECH VENT FOR ENCLSD STOR AREAS MUST MEET NATL ELEC(ING 20)
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
VP:590 PSIA W 62.2F. SOL IN H*2O:1 ATM 1 CUFT/CUFTH*2O @ 64F.
APPEAR/ODOR:ACETYLENE IMPART CHARACT GARLIC-LIKE ODOR. FIRE FIGHT
PROC:FIRE. KEEP PERS WELL AWAY SINCE CNTNRS CAN RUPTURE VIOLENTLY
WHEN E XPOS TO FIRE. FOR ADDNL INFO, SEE COMPRESSED GAS ASSOC SFTY
BULLETIN SB-4. EXPLO HAZ:EXPLO HAZ EXISTS FROM (ING 2)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:-119F,-84C
Melt/Freeze Pt:M.P/F.P Text:-113F,-81C
Vapor Pres:SUPP DATA
Vapor Density:1
Spec Gravity:0.906 (AIR=1)
Solubility in Water:SUPP DATA
Appearance and Odor:PURE ACETYLENE IS COLORLESS & ODORLESS. IMPURITIES
IN CARBIDE GENERATED (SUPDAT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS SUCH AS OXYG & HALOGENS. FORMS EXPLO CMPDS W/COPPER, BRASS,
COPPER SALTS, MERCURY & MERCURY SALTS, (ING 6)
Stability Condition to Avoid:NEVER UTILIZE FREE GAS OUTSIDE CYL OF
PRESS IN EXCESS OF 15 PSIG. AVOID MECH SHOCKS TO CNTNRS OF
ACETYLENE. (ING 5)
Hazardous Decomposition Products:ACETYLENE WILL DECOMPOSE INTO
ELEMENTAL CARBON & HYDROGEN UNDER ABOVE CONDITION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT ATTEMPT TO DISPOSE OF RESIDUAL GAS IN
CYLINDERS. RETURN CYLINDERS TO WESTERN INTERNATIONAL FOR DISPOSAL.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PR-1758, PART B
Kit Part:Y
Preparer's Name:MBY
CAGE:DO563
CAGE:83574
CAGE:DO563
============= Composition/Information on Ingredients =============
Ingred Name:PHENOL POLYMER WITH FORMALDEHYDE (PHENOLIC RESIN)
CAS:9003-35-4
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE:IRRITANT. SKIN:LOCAL IRRITANT. MAY
CAUSE ALLERGIC RASHES IN SENSITIZED INDIVIDUALS. INHAL:CAN CAUSE
THROAT IRRITATION. INGEST:MAY CAUSE NAUSEA, VOMITING & ABDOMINAL
PAIN. MAY CAUSE KIDNEY & LIVER DAMAGE.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH W/LUKE WARM WATER FOR AT LEAST 15 MINUTES. IF
SYMPTOMS PERSIST, CALL MD. SKIN:WASH W/SOAP & WATER. IF SYMPTOMS
PERSIST, CALL MD. INHAL:REMOVE TO FRESH AIR. IF SYMPTOMS PRESENT,
CALL MD. INGE ST:INDUCE VOMITING.
===================== Fire Fighting Measures =====================
Flash Point:NOT FLAMMABLE
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM, WATER
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED AIR-SUPPLIED
RESPIRATOR & FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE KNOWN.
================== Accidental Release Measures ==================
Spill Release Procedures:SCOOP INTO CONTAINERS. CLEAN UP RESIDUE
W/1,1,1 -TRICHLOROETHANE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:GENERAL VENTILATION.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
KEY1:N1.
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:1.46
Solubility in Water:NEGLIGIBLE
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDANTS
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CO*X, SO*2, TRACES OF H*2S.
==================== Disposal Considerations ====================
Waste Disposal Methods:NOT A HAZARDOUS WASTE ACCORDING TO EPA
REGULATIONS. CONSULT STATE REGULATIONS PRIOR TO DISPOSAL OF
SPILLAGE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:186 2135 EKTAPRINT 2 DEVELOPER,PART A
Kit Part:Y
CAGE:19139
CAGE:19139
============= Composition/Information on Ingredients =============
Ingred Name:BENZYL ALCOHOL
CAS:100-51-6
RTECS #:DN3150000
Fraction by Wt: 50 - 55%
Other REC Limits:NONE SPECIFIED
Ingred Name:TRIETHANOLAMINE
CAS:102-71-6
RTECS #:KL9275000
Fraction by Wt: 30 - 35%
Other REC Limits:NONE SPECIFIED
Ingred Name:STILBENE BRIGHTENER - NON-HAZARDOUS PER MSDS. PREVIOUSLY
WAS WATER (10-15%)
Fraction by Wt: 1 - 5%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE-INHALATION:VAPOR HAS A
DISAGREEABLE ODOR.MAY CAUSE IRRITATION OF THE UPPER RESPIRATORY
TRACT IN SOME INDIVIDUAL.EYES/SKIN:CAUSES
IRRITATION.INGESTION:HARMFUL.CHRONIC-NOT GIVEN.
Explanation of Carcinogenicity:THIS PRODUCT CONTAINS NO INGREDIENT
LISTED AS CARCINOGEN BY IARC,NTP, OR OSHA.
Effects of Overexposure:SEE HEALTH HAZARDS SECTION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:GET MEDICAL ATTENTION.EYE:IMMEDIATELY FLUSH WITH WATER FOR AT
LEAST 15 MINUTES.SKIN:FLUSH WITH PLENTY OF WATER.WASH WITH SOAP &
WATER.INHALATION:REMOVE TO FRESH AIR.INGESTION:CALL A PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WATER SPRAY; CARBON DIOXIDE; DRY CHEMICAL
Fire Fighting Procedures:USE SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING TO PREVENT CONTACT WITH SKIN AND EYES.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY CAUSE
PRODUCTION OF HAZARDOUS DECOMPOSITION PRODUCTS.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH SMALL SPILLS TO THE SEWER WITH LARGE
AMOUNT OF WATER.ABSORB LARGE SPILLS WITH INERT MATERIAL AND PLACE
IN A CONTAINER FOR CHEMICAL WASTE.PREVENT RUNOFF FROM ENTERING
DRAINS,SEWERS AND STREAMS.FL USH RESIDUAL SPILL AND AREA WITH
WATER.
Neutralizing Agent:WEAK ACID
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE-KEEP FROM CONTACT WITH
OXIDIZING MATERIALS.
Other Precautions:AVOID BREATHING VAPORS OR MIST. AVOID CONTACT WITH
EYES,SKIN,OR CLOTHING. WASH THOROUGHLY AFTER HANDLING.USE
VENTILATION THAT IS ADEQUATE TO KEEP EMPLOYEE EXPOSURE TO AIRBORNE
CONCENTRATIONS BELOW REC OMMENDED EXPOSURE LIMITS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESPIRATORS ARE NOT NEEDED FOR NORMAL USE.A
NIOSH/MSHA APPROVED AIR PURIFYING RESPIRATOR WITH AN ORGANIC VAPOR
CARTRIDGE/CANISTER WITH DUST/MIST FILTER OR A POSITIVE PRESSURE AIR
SUPPLIED RESPIRATOR W HERE AIRBORNE CONCENTRATIONS > TLV.
Ventilation:GOOD GENERAL VENTILATION SHOULD BE SUFFICIENT.
Other Protective Equipment:EYE WASH STATION & SAFETY SHOWER.IMPERVIOUS
CLOTHING SUCH AS BOOTS,APRON,WHOLE BODY SUIT MADE FROM NEOPRENE.
Work Hygienic Practices:USE OF A NON-ALKALINE TYPE OF SKIN CLEANSER AND
REACTION.
Supplemental Safety and Health
ITEM IS 4 PARTS PRODUCT WHICH CONSISTS OF EKTAPRINT 2 DEVELOPER,PARTS
A,B,C & D;THE OLD CAT #121 6167 WAS CHANGED BY CO DURING 1981,SAME
STOCK NO;BEFORE 3/81 CAT #121 6167(P/N IND A-D), AFTER 3/81 CAT
#186 2135 (SEE P/N IND E-H). THIS ENTRY OF EKTAPRINT 2 DEVELOPER,
PART A, SOLUTION #4483; KEY1:C4.
================== Physical/Chemical Properties ==================
HCC:B3
Boiling Pt:B.P. Text:>212F,>100C
Vapor Pres:13
Vapor Density:3.2
Spec Gravity:1.08
pH:10.6
Solubility in Water:COMPLETE
Appearance and Odor:AMBER LIQUID, AMINE ODOR
Percent Volatiles by Volume:65
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH TEMPERATURES AND FLAMES
Hazardous Decomposition Products:CARBON DIOXIDE AND PROBABLY CARBON
MONOXIDE. OXIDES OF NITROGEN MAY BE PRESENT. AMMONIA
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTRACT WITH LICENSED CHEMICAL WASTE DISPOSAL
AGENCY. FEDERAL, STATE, AND LOCAL REGULATIONS TAKE PRECEDENCE.
| 1 | gloves_mandatory |
=======================================================
NIIN: 01-412-0992
Product ID: AEROSOL INDUSTRIAL SOLVENT, DEGREASER
Cage: 27674
Box: 2015
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 27674
Box: 2015
=======================================================
Item Description Information
=======================================================
Item Manager: GSA
Item Name: CLEANING COMPOUND,SOLVENT-DETERGENT
Unit of Issue: BX
Quantitative Expression: 00000000024EA
UI Container Qty: 1
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE: SEVERE EYE IRRIT. PERMANENT TISSUE DAMAGE.
INHALATION MAY PRODUCE UPPER RESPIRATORY IRRIT;SKIN IRRIT. ONE OF THE
INGREDIENTS IN THIS PRODUCT HAS CAUSED SENSITIZATION REACTIONS IN SMALL
PERCENTA GE OF POPULATION. CHRONIC: CHRONIC SKINCONTACT MAY CAUSE
INFLAMMATION/DERMATITIS.
Medical Cond Aggravated By Exposure: INGREDIENTS IN THIS PRODUCT MAY AGGRAVATE
EXISTING SKIN, EYE OR RESPIRATORY DISORDERS.
First Aid: SKIN: FLUSH CONTAMINATED SKIN W/PLENTY WATER. CALL DR IF IRRIT
DEVELOPS. EYES: IMMEDIATELY FLUSH W/PLENTY WATER >15 MIN, OCCASIONALLY
LIFTING UPPER/LOWER LIDS. GET MED AID AT ONCE. INHALATION: MOVE TO FRESH
AIR. IF IRRIT PERSISTS GET MED AID PROMPTLY. INGESTION: DO NOT INDUCE
VOMITING. IF VOMITING KEEP HEAD BELLOW HIP LEVEL. IF VICTIM CONSCIOUS GIVE
PLENTY OF WATER TO DRINK. GET MED AID AT ONCE.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: OBSERVE SAFETY PRECAUTIONS DURING CLEAN-UP. LARGE
SPILLS UNLIKELY DUE TO PACKAGING. ABSORB SPILL ON INERT ABSORBENT AND PLACE
IN SUITABLE CONTAINER FOR DISPOSAL. WASH AREA THOROUGHLY W/DETERGENT SOLUT
ION, RINSE WELL W/WATER.
Waste Disposal Methods: PRODUCT CONSUMED IN USE. DON'T
CRUSH/PUNCTURE/INCINERATE SPENT CNTNRS. LG NUMBERS AEROSOL CNTNRS MAY REQ
HANDLING AS HAZ WASTE. MAY DISPOSE TOTAL HAZ WASTE WT <220 LBS PER MONTH
IN CHEM/INDUST LANDFIL L IN MOST STATES. CONSULT ALL APPLICABLE REGS.
Handling And Storage Precautions: FLAMMABLE. STORE/USE AWAY FROM
HEAT/SPARKS/OPEN FLAME/IGNIT SOURCES. DON'T STORE ABOVE 120F OR IN DIRECT
SUNLIGHT. DON'T PUNCTURE/INCINERATE CNTNR.
Other Precautions: KEEP PRODUCT AWAY FROM SKIN/EYES. DON'T BREATHE SPRAY,
MISTS, VAPORS. REMOVE CONTAMINATED CLOTHES/SHOES PROMPTLY & DON'T WEAR
UNTIL THOROUGHLY CLEANED. KEEP AWAY FROM CHILDREN.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: FLAMMABLE
Lower Limits: NA
Upper Limits: NA
Extinguishing Media: CO2, DRY CHEMICAL, WATER FOG, FOAM.
Fire Fighting Procedures: WEAR POSITIVE PRESSURE SCBA.
Unusual Fire/Explosion Hazard: DIRECT WATER ONTO IN TACT CONTAINERS TO PREVENT
BURSTING.
=======================================================
Control Measures
=======================================================
Respiratory Protection: KEEP FACE AWAY FROM SPRAY/MISTS. DON'T BREATHE VAPORS.
Ventilation: PROVIDE LOCAL EXHAUST VENTILATION AS NEEDED TO KEEP CONCENTRATION
BELOW EXPOSURE LIMIT.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: 310 TO 365F
Vapor Pres: NA
Vapor Density: NA
Spec Gravity: 0.812
PH: NA
Solubility in Water: NEGLIGIBLE
Appearance and Odor: CLEAR COLORLESS LIQUID, CITRUS ODOR
Percent Volatiles by Volume: 100.0
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: HEAT, FLAMES, SPARKS.
Materials To Avoid: STRONG ACIDS &/OR OXIDIZERS.
Hazardous Decomposition Products: CARBON DIOXIDE, CARBON MONOXIDE, OTHER
UNIDENTIFIED ORGANIC COMPOUNDS.
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
Transportation Information
=======================================================
Trans ID NO: 134701
Product ID: AEROSOL INDUSTRIAL SOLVENT, DEGREASER
Review Date: 06/05/1996
Multiple KIT Number: 0
Review IND: Y
Unit Of Issue: BX
Container QTY: 1
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: DTJ
Symbols: D
DOT Proper Shipping Name: CONSUMER COMMODITY
Hazard Class: ORM-D
Label: NONE
Non Bulk Pack: 156,306
Bulk Pack: NONE
Max Qty Pass: 30KGGROSS
Max Qty Cargo: 30KGGROSS
Vessel Stow Req: A
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: AKH
IMO Proper Shipping Name: AEROSOLS/AEROSOL PRODUCT ?
IMDG Page Number: SEE 9022
UN Number: 1950
UN Hazard Class: 9?
IMO Packaging Group: -
Subsidiary Risk Label: -
EMS Number: 2-13
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: ALS
IATA UN ID Num: 1950
IATA Proper Shipping Name: AEROSOLS, FLAMMABLE
IATA PSN Modifier: (EACH NOT EXCEEDING 1 L CAPACITY)
IATA UN Class: 2.1
IATA Label: FLAMMABLE GAS
Packing Note Passenger: 203
Max Quant Pass: 75KG
Max Quant Cargo: 150KG
Packaging Note Cargo: 203
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: ALR
AFI Symbols: *
AFI Proper Shipping Name: AEROSOLS, FLAMMABLE, N.O.S.
AFI PSN Modifier: (EACH NOT EXCEEDING 1L CAPACITY)
AFI Hazard Class: 2.1
AFI UN ID NUM: UN1950
Special Provisions: P4
Back Pack Reference: A6.3
=======================================================
HAZCOM Label
=======================================================
Product ID: AEROSOL INDUSTRIAL SOLVENT, DEGREASER
Cage: 27674
Company Name: ZEP MANUFACTURING COMPANY
Street: 1310 SEABOARD INDUSTRIAL BLVD NW
PO Box: 2015
Zipcode: 30318
Label Required IND: Y
Date Of Label Review: 12/16/1998
Status Code: C
Label Date: 12/16/1998
Origination Code: G
Hazard And Precautions: ACUTE: SEVERE EYE IRRIT. PERMANENT TISSUE DAMAGE.
INHALATION MAY PRODUCE UPPER RESPIRATORY IRRIT;SKIN IRRIT. ONE OF THE
INGREDIENTS IN THIS PRODUCT HAS CAUSED SENSITIZATION REACTIONS IN SMALL
PERCENTA GE OF POPULATION. CHRONIC: CHRONIC SKINCONTACT MAY CAUSE
INFLAMMATION/DERMATITIS.NK
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ROYCO 46
Preparer's Name:PRODUCT SAFETY
CAGE:07950
CAGE:07950
============= Composition/Information on Ingredients =============
Ingred Name:SYNTHETIC ESTER
CAS:122-62-3
Fraction by Wt: 80-90%
Ingred Name:PETROLEUM SULFONATE
CAS:25619-56-1
Fraction by Wt: <2.0%
Ingred Name:DIISOPROPYL HYDROGEN PHOSPHITE
CAS:1809-20-7
RTECS #:SZ7660000
Fraction by Wt: <2.0%
Ingred Name:OTHER COMPONENTS (TYPE NOT SPECIFIED)
Fraction by Wt: <10.0%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NO ACGIH TLV HAS BEEN ESTABLISHED.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE-PRODUCT IS PRESUMED TO BE
IRRITATING TO THE EYES. SKIN-PROLONGED OR REPEATED CONTACT MAY
CAUSE VARIOUS SKIN DISORDERS SUCH AS DERMATITIS, FOLLICULITIS OR
OIL ACNE. . INHALATION-UNDER HIGH TEMPERAT URE CONDITIONS, VAPORS
IRRITATING TO THE NOSE, THROAT & UPPER RESPIRATORY TRACT.
Explanation of Carcinogenicity:DATA PER MSDS
Effects of Overexposure:IRRITATION AS NOTED ABOVE. LOCAL NECROSIS IS
EVIDENCED BY DELAYED ONSET OF PAIN AND TISSUE DAMAGE A FEW HOURS
FOLLOWING INJECTION.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN DISORDERS MAY BE
AGGRAVATED BY EXPOSURE TO THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:EYE-FLUSH WITH WATER FOR 15 MIN WHILE HOLDING EYELIDS OPEN.
GET MEDICAL ATTENTION. SKIN-REMOVE SOLIED CLOTHES, WIPE OFFF
EXCESS. WASH WITH SOAP & WATER OR A WATERLESS HAND CLEANER FOLLOWED
BY SOAP & W ATER. SEE PHYSICIAN FOR IRRITATION. INHALATION-REMOVE
VICTIM TO FRESH AIR & PROVIDE OXYGEN IF BREATHING IS DIFFICULT, GET
MEDICAL ATTENTION. INGESTION-DO NOT INDUCE VOMITING. NO TREATMENT
IS NEEDED.
===================== Fire Fighting Measures =====================
Flash Point:>200F,>93C
Extinguishing Media:USE CARBON DIOXIDE, DRY CHEMICAL, OR WATER FOG. DO
NOT USE A DIRECT STREAM OF WATER. PRODUCT WILL FLOAT & REIGNITE.
Fire Fighting Procedures:DO NOT ENTER CONFINED FIRE SPACE WITHOUT
PROPER PROTECTIVE EQUIPMENT INCLUDING A NIOSH APPROVED
SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:COOL FIRE EXPOSED CONTAINERS SURROUNDING
EQUIPMENT & STRUCTURES WITH WATER.
================== Accidental Release Measures ==================
Spill Release Procedures:SCOOP UP EXCESS GREASE. CLEAN AREA WITH
APPROPIATE CLEANER.
Neutralizing Agent:NOT APPLICABLE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE WITH
ADEQUATE VENTILATION. KEEP AWAY FROM OPEN FLAMES & HIGH
TEMPERATURES.
Other Precautions:WASTE DISOSAL: ALTERNATIVELY, THE MATERIAL MAY BE
RECYCLED, CURRENTLY, HAZARDOUS USED OIL THAT IS RECYCLED BY BEING
BURNED FOR ENERGY RECOVERY IS MINIMALLY REGULATED UNDER RCRA.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT ORDINARILY REQUIRED.
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:USE CLOTHING AS NEEDED TO MINIMIZE SKIN
CONTACT.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
NONE.
================== Physical/Chemical Properties ==================
HCC:V6
Solubility in Water:INSOLUBLE
Appearance and Odor:TAN, SEMI-FLUID, SLIGHT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:AVOID HEAT, AND OPEN FLAMES.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE AND
OTHER UNIDENTIFIED COMPONENTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:THIS PRODUCT CONTAINS BARIUM AT GREATER THAN 100
MG/L. UNDER EPA - RCRA (40CFR 261.24). A WASTE MATERIAL CONTAINING
BARIUM IS (HAZARDOUS WASTE#D0005). REFER TO THE LATEST EPA OR
STATE REGULATIONS RE GARDING DISPOSAL.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:AUTOMOBILE POLISH, LIQUID, W/SILICONE
Preparer's Name:LEWYN B. BOLER
CAGE:PR0DU
CAGE:PR0DU
============= Composition/Information on Ingredients =============
Ingred Name:ABRASIVE
Fraction by Wt: 20%
Other REC Limits:NONE SPECIFIED
Ingred Name:SOLVENT
CAS:64742-86-5
RTECS #:LX3296500
Fraction by Wt: 57%
Other REC Limits:NONE SPECIFIED
Ingred Name:PARAFFIN WAX
CAS:8002-74-2
RTECS #:RV0350000
Fraction by Wt: 1.5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:2 MG/M3 (FUME)
ACGIH TLV:2 MG/M3 (FUME); 9192
Ingred Name:EMULSIFIER
Fraction by Wt: 1%
Other REC Limits:NONE SPECIFIED
Ingred Name:SILICONE FLUID
CAS:63148-62-9
Fraction by Wt: 6%
Other REC Limits:NONE SPECIFIED
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 14.5%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Health Hazards Acute and Chronic:EYES:CAN CAUSE SEVERE IRRITATION,
BLURRED VISION. BREATHING:CAN CAUSE NASAL & RESPIRATORY IRRITATION,
DIZZINESS, WEAKNESS. SKIN:CAN CAUSE MODERATE IRRITATION, DEFATTING,
DERMATITIS.
Effects of Overexposure:EYES:CAN CAUSE SEVERE IRRITATION, BLURRED
VISION. BREATHING: CAN CAUSE NASAL & RESPIRATORY IRRITATION,
DIZZINESS, WEAKNESS. SKIN:CAN CAUSE MODERATE IRRITATION, DEFATTING,
DERMATITIS.
======================= First Aid Measures =======================
First Aid:SKIN:WASH EXPOSED AREA WITH SOAP & WATER. EYES:FLUSH WITH
LARGE AMOUNTS OF WATER, LIFTING UPPER AND LOWER LIDS. GET MEDICAL
ATTENTION. SWALLOWED:DO NOT INDUCE VOMITING, KEEP PERSON WARM,
QUIET AND GET MEDICAL ATTENTION. BREATHED:REMOVE INDIVIDUAL TO
FRESH AIR. IF BREATHING IS DIFFICULT ADMINISTER OXYGEN. IF
BREATHING IS STOPPED GIVE ARTIFICIAL RESPIRATION AND GET MEDICAL
ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:102F/38C
Autoignition Temp:Autoignition Temp Text:500F
Lower Limits:1.0
Upper Limits:6.0
Extinguishing Media:CO2, DRY CHEMICAL, FOAM, WATER SPRAY
Fire Fighting Procedures:SELF-CONTAINED BREATHING APPARATUS WITH A FULL
FACEPIECE OPERATED IN PRESSURE DEMAND.
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR & MAY TRAVEL
ALONG THE GROUND OR BE MOVED BY VENTILATION & IGNITED BY HEAT,PILOT
LIGHTS OR IGNITION SOURCES AWAY FROM HANDLING POINT
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB LIQUID ON PAPER, VERMICULITE, FLOOR
ABSORBENT, OR OTHER ABSORBENT MATERIAL AND TRANSFER TO HOOD.
ELIMINATE ALL IGNITION SOURCES AND PERSONS NOT WEARING PROTECTIVE
EQUIPMENT FROM AREA UNTIL CLEA N-UP HAS BEEN COMPLETED.
======================Handling and Storage ======================
Handling and Storage Precautions:CONTAINERS OF THIS MATERIAL MAY BE
HAZARDOUS WHEN EMPTIED SINCE EMPTIED CONTAINERS RETAIN PRODUCT
RESIDUES (VAPOR, LIQUID, AND/OR SOLID).
Other Precautions:ALL HAZARD PRECAUTIONS GIVEN IN THE DATA SHEET MUST
BE OBSERVED
============= Exposure Controls/Personal Protection =============
Respiratory Protection:A NIOSH/MSHA JOINTLY APPROVED AIR SUPPLIED
RESPIRATOR IS ADVISED IN ABSENCE OF PROPER ENVIRONMENTAL CONTROL.
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL AND/OR LOCAL
EXHAUST) VENTILATION TO MAINTAIN EXPOSURE BELOW TLV'S.
Other Protective Equipment:WEAR IMPERVIOUS CLOTHING AND BOOTS TO
PREVENT PROLONGED SKIN CONTACT.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:212F/100C
Melt/Freeze Pt:M.P/F.P Text:NONE
Decomp Temp:Decomp Text:500F/260C
Vapor Density:.8
Spec Gravity:0.78
pH:7
Evaporation Rate & Reference:0.22 (BUAC=1)
Solubility in Water:THICKENS NON-DISPERS
Appearance and Odor:THIN YELLOW LIQUID SOLVENT-LIKE ODOR
Percent Volatiles by Volume:71.5
Corrosion Rate:SULF1PPM
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS
Hazardous Decomposition Products:NORMAL COMBUSTION FORMS CARBON DIOXIDE
& WATER VAPOR. INCOMPLETE COMBUSTION CAN PRODUCE CARBON MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:ALLOW VOLATILE PORTION TO EVAPORATE IN HOOD.
ALLOW TIME FOR VAPORS TO COMPLETELY CLEAR HOOD DUCT WORK. DISPOSE
OF REMAINING MATERIAL IN ACCORDANCE WITH APPLICABLE REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MERCURY (IC) CHLORIDE
CAGE:1B464
CAGE:1B464
============= Composition/Information on Ingredients =============
Ingred Name:MERCURY(II) CHLORIDE, MERCURIC CHLORIDE
CAS:7487-94-7
RTECS #:OV9100000
Fraction by Wt: 100%
Other REC Limits:0.05 MG/CUM HG MSHA
ACGIH TLV:0.1 MG/CUM HG
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT): 1 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:IMMEDIATELY DANGEROUS TO
LIFE.INHALATION: SORT THROAT, COUGH, FEVER, NAUSEA, VOMITING, MOUTH
INFLAMMATION, SALIVATION, METALLIC TASTE. SKIN: REDNESS,
IRRITATION, SENSITIZATION DERMATITIS. EYES: BURNS INGESTION: MOUTH
NECROSIS, THROAT, ESOPHAGUS & STOMACH, VIOLENT PAIN, VOMITING,
PURGING & GASTROINTESTINAL DISTRESS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: MERCURIALISM, MOUTH INFLAMMATION,
TEETH LOOSENING, BLUE LINE ON GUMS, PAIN & NUMBNESS IN EXTREMITIES,
MENTAL DEPRESSION, INSOMNIA, HALLUCINATIONS. SKIN: ABSORPTION,
PSYCHIC DISTURBANCES, P ERIPHERAL NEUROPATHY & LIVER/KIDNEY DAMAGE.
INGESTION: RENAL FAILURE LEADING TO DEATH, PERIPHERAL VASCULAR
COLLAPSE.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. IF BREATHING STOPS, GIVE
ARTIFICIAL RESPIRATION. MAINTAIN AIRWAY & BLOOD PRESSURE.
ADMINISTER OXYGEN IF AVAILABLE. KEEP WARM & AT REST. SKIN: WASH
W/SOAP OR MILD DETER GENT & FLUSH W/WATER. EYES: FLUSH W/PLENTY OF
WATER FOR 10-20 MINS. INGESTION: IF CONSCIOUS, GIVE 2-4 GLASSES OF
WATER & INDUCE VOMITING BY TOUCHING FINGER TO BACK OF THROAT.
OBTAIN MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Extinguishing Media:DRY CHEMICAL, CO2, WATER SPRAY, FOG, ALCOHOL FOAM
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS W/FULL
FACEPIECE OPERATED IN PRESSURE-DEMAND OR OTHER POSTIVE PRESSURE
MODE. MOVE CONTAINERS FROM AREA IF POSSIBLE.
Unusual Fire/Explosion Hazard:USE WATER IN FLOODING AMOUNTS AS FOG.
AVOID BREATHING POISONOUS DUSTS & FUMES FROM BURNING MATERIAL.
================== Accidental Release Measures ==================
Spill Release Procedures:DON'T TOUCH SPILLED MATERIAL. STOP LEAK IF YOU
CAN DO IT WITHOUT RISK. TAKE UP W/SAND OR OTHER ABSORBENT MATERIAL
& PLACE INTO CONTAINERS. MOVE CONTAINERS FROM SPILL AREA. DIKE FAR
AHEAD OF SPILL. KEE P UNNECESSARY PEOPLE AWAY. ISOLATE AREA.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE APPROPRIATE RESPIRATOR: SUPPLIED-AIR
RESPIRATOR, SELF-CONTAINED BREATHING APPARATUS, SUPPLIED-AIR
RESPIRATOR W/FULL FACEPIECE, HELMET, HOOD, OR TYPE-C OPERATED IN
PRESSURE-DEMAND OR OTHER POSITIVE PRESSURE MODE IN CONTINUOUS-FLOW
MODE.
Ventilation:LOCAL EXHAUST TO MEET EXPOSURE LIMITS
Other Protective Equipment:FACESHIELD, IMPERVIOUS CLOTHING, EYE-WASH
FOUNTAIN
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING & SHOES
BEFORE REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:576F/302C
Melt/Freeze Pt:M.P/F.P Text:529F/276C
Spec Gravity:5
pH:4.7
Solubility in Water:6.9%
Appearance and Odor:WHITE CRYSTALS OR POWDER, ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
POTASSIUM, SODIUM
Stability Condition to Avoid:EXTREME TEMPERATURES & PRESSURES
Hazardous Decomposition Products:BOILS AWAY UNCHANGED AT 302C
Conditions to Avoid Polymerization:HAS NOT BEEN REPORTED TO OCCUR UNDER
NORMAL TEMPERATURES & PRESSURES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:2751-01 ENAMEL BONDING/GLAZE/LTCURING AGENT
CAGE:64397
CAGE:64397
============= Composition/Information on Ingredients =============
Ingred Name:ACTIVATORS
Fraction by Wt: <1.0%
Ingred Name:STABILIZERS
Fraction by Wt: <1.0%
Ingred Name:AROMATIC AND ALIPHATIC DIMETHACRYLATE MONOMERS
Fraction by Wt: 99.00%
Ingred Name:ACCELERATORS
Fraction by Wt: <1%
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL RATS LD50 - >5000 MG/KG
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION. SKIN: REPEATED
CONTACT MAY CAUSE REDDENING & IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES: IRRITATION. SKIN: REPEATED CONTACT MAY
CAUSE REDDENING & IRRITATION.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH COPIOUS QUANTITIES OF WATER FOR 15 MIN. SEEK
MED ATTN. SKIN: WASH W/SOAP & WATER.
===================== Fire Fighting Measures =====================
Extinguishing Media:DRY CHEMICAL FOAM, CO2, DRY CHEMICAL
Fire Fighting Procedures:USE PROTECTIVE GEAR. USE WATER FOG TO COOL
LARGE CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:MATERIAL MAY BURN IF EXPOSED TO FLAME.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB ONTO VERMICULITE OR CLAY. SCOOP UP &
DISPOSE INTO ACCEPTABLE CONTAINERS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM IGNITION SOURCES.
PROTECT FROM HIGH HEAT. KEEP CONTAINERS CLOSED WHEN NOT IN USE.
AVOID CONTACT W/SKIN.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED
Other Protective Equipment:NONE
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Spec Gravity:1.2
Appearance and Odor:TRANSPARENT LIGHT AMBER LIQUID, CHARACTERISTIC
METHACRYLATE ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:IGNITION SOURCES, ELEVATED TEMPERATURES,
HEAT, FLAME.
Conditions to Avoid Polymerization:ELEVATED TEMPERATURES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL REGULATIONS FOR
RELATIVELY NON-TOXIC ORGANICS. AVOID CONDITIONS WHICH MAY RESULT IN
DISPERSION TO STREAMS OR WATERWAYS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:THINNER,PAINT PRODUCTS
Preparer's Name:ERNEST CARTER
CAGE:0A9L8
CAGE:0A9L8
============= Composition/Information on Ingredients =============
Ingred Name:LIGHT ALIPHATIC SOLVENT NAPHTHA (PETROLEUM)
CAS:64742-89-8
> Wt:16.
Ingred Name:ISOBUTYL ACETATE
CAS:110-19-0
RTECS #:AI4025000
> Wt:35.
OSHA PEL:700 MG/M3;150 PPM
ACGIH TLV:713 MG/M3;150 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TOLUENE
CAS:108-88-3
RTECS #:XS5250000
> Wt:12.
OSHA PEL:SEE TABLE Z-2
ACGIH TLV:188 MG/M3;50 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ISO-PROPYL ALCOHOL
CAS:67-63-0
RTECS #:NT8050000
> Wt:10.
OSHA PEL:980 MG/M3;400 PPM
ACGIH TLV:983 MG/M3;400 PPM
ACGIH STEL:1230 MG/M3;500 PPM
Ingred Name:METHYL ETHYL KETONE
CAS:78-93-3
RTECS #:EL6475000
> Wt:.15
OSHA PEL:590 MG/M3;200 PPM
ACGIH TLV:590 MG/M3;200 PPM
ACGIH STEL:885 MG/M3;300 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ISOBUTYL ALCOHOL
CAS:78-83-1
RTECS #:NP9625000
> Wt:.12
OSHA PEL:300 MG/M3;100 PPM
ACGIH TLV:152 MG/M3;50 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:EYES: FLUSH THOROUGHLY WITH WATER FOR
AT LEAST 15 MINUTES. SKIN: WASH EXPOSED AREA WITH SOAP AND WATER.
INGESTION: DO NOT INDUCE VOMITING. INHALATION: REMOVE PERSON TO
FRESH AIR.
Effects of Overexposure:HEADACHE,DIZZINESS, NAUSEA,AND LOSS OF
COORDINATION ARE INDICATIONS OF EXCESSIVE EXPOSURE TO VAPORS OR
SPRAY MISTS. REDNESS AND ITCHING OR BURNING SENSATION MAY INDICATE
EYE OR EXCESSIVE SKIN EXPOSURE .
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.
======================= First Aid Measures =======================
First Aid:IF INHALATION: IF AFFECTED, REMOVE FROM EXPOSURE.RESTORE
BREATHING. KEEP WARM AND QUIET.. IF ON SKIN: WASH AFFECTED AREA
THOROUGHLY WITH SOAP AND WATER. REMOVE CONTAMINATED CLOTHING AND
LAUNDER BEFORE RE-USE. IF IN EYES: FLUSH EYES WITH LARGE AMOUNTS
OF WATER FOR 15 MINUTES. GET MEDICAL ATTENTION. IF SWALLOWED: NEVER
GIVE ANYTHING BY MOUTH TO AN UNCONIOUS PERSON. DO NOT INDUCE
VOMITING. GIVE CONSC IOUS PATIENT SEVERAL GLASSES OF WATER. SEEK
MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:CALC
Flash Point:=37.8C, 100.F
Lower Limits:1.0
Upper Limits:6.0
Extinguishing Media:CARBON DIOXIDE, CHEMICAL FOAM,
Fire Fighting Procedures:FULL PROTECTIVE EQUIPMENT INCLUDING
SELF-CONTAINED BREATHING APPARATUS SHOULD BE USED. WATER SPRAY MAY
BE INEFFECTIVE. IF WATER IS USED, FOG NOZZLES ARE PREFERABLE.
WATER MAY BE USED TO COOL CLOSED C ONTAINERS TO PREVENT PRESSURE
BUILD-UP POSSIBLE AUTOIGNITION OR EXPLOSION WHEN EXPOSED TO EXTREME
HEAT.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE
FROM HEAT, ELECTRICAL EQUIPMENT, SPARKS, AND OPEN FLAME. CLOSED
CONTAINERS MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT. APPLICATION TO
HOT SURFACES REQUIRES SPECIA L PRECAUTIONS. DURING EMERGENCY
CONDITIONS OVEREXPOSURE TO DECOMPOSITION PRODUCTS MAY CAUSE A
HEALTH HAZARD
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN SPILL. REMOVE WITH INERT ABSORBENT.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT AND OPEN FLAME.
CONSULT NFPA CODE. USE . APPROVED BONDING AND GROUNDING PROCEDURES.
KEEP CONTAINER CLOSED WHEN NOT IN USE. TRANSFER ONLY TO APPROVED
COMTAINERS WITH COMPLETE AND AP PROPRIATE LABELING. DO NOT TAKE
INTERNALLY. KEEP OUT OF THE REACH OF CHILDREN..
Other Precautions:INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING AND
INHALING THE CONTENTS CAN BE HARMFUL OR FATAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR A DUST/MIST RESPIRATOR APPROVED BY
NIOSH/MSHA FOR DUST WHICH MAY BE GENERATED FROM THIS
PRODUCT,UNDERLYING PAINT, OR THE ABRASIVE.
Ventilation:LOCAL EXHAUST PREFERABLE.
FOR PROTECTION
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:=78.C, 172.4F
Vapor Pres:(MM HG): 37.1 @68 F (20 C
Vapor Density:(AIR=1)
Spec Gravity:0.82 @ 60 F ( 15.6 C )
Appearance and Odor:COLORLESS,KETONE ODOR
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME.
Hazardous Decomposition Products:CARBON MONOXIDE FROM BURNING.
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT INCINERATE CLOSED CONTAINER. DISPOSE OF
IN ACCORDANCE WITH FEDERAL, STATE, AND LOCAL REGULATIONS REGARDING
POLLUTION.
======================================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:31013, REGULAR CLEAR PVC SOLVENT CEMENT
Resp. Party Other MSDS Num.:31013- 8 OZ
CAGE:53472
CAGE:53472
============= Composition/Information on Ingredients =============
Ingred Name:PVC RESIN (NON-HAZARDOUS)
CAS:9002-86-2
RTECS #:KV0350000
Minumum % Wt:10.
Maxumum % Wt:14.
Ingred Name:TETRAHYDROFURAN
CAS:109-99-9
RTECS #:LU5950000
Minumum % Wt:25.
Maxumum % Wt:40.
OSHA PEL:590 MG/M3;200 PPM
ACGIH TLV:590 MG/M3;200 PPM
ACGIH STEL:737 MG/M3;250 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ACETONE
CAS:67-64-1
RTECS #:AL3150000
< Wt:1.
OSHA PEL:2400 MG/M3;1000 PPM
ACGIH TLV:1780 MG/M3;750 PPM
ACGIH STEL:2380 MG/M3;1000 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:METHYL ETHYL KETONE
CAS:78-93-3
RTECS #:EL6475000
Minumum % Wt:40.
Maxumum % Wt:55.
OSHA PEL:590 MG/M3;200 PPM
ACGIH TLV:590 MG/M3;200 PPM
ACGIH STEL:885 MG/M3;300 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:CYCLOHEXANONE
CAS:108-94-1
RTECS #:GW1050000
Minumum % Wt:5.
Maxumum % Wt:10.
OSHA PEL:200 MG/M3;50 PPM
ACGIH TLV:100 MG/M3;25 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE PROVIDED BY MFR.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS: EYE, SKIN, KIDNEY,
LUNG, LIVER, CENTRAL NERVOUS SYSTEM. INHALATION: HAS CAUSED CNS
DEPRESSION & LIVER DAMAGE IN ANIMALS, & HIGH CONCENTRATIONS HAVE
CAUSED RETARDATION OF FETAL DEVELOPME NT IN RATS. INGESTION: MAY BE
ASPIRED INTO THE LUNGS OR CAUSE SYSTEMIC EFFECTS DESCRIBED UNDER
INHALATION. EYES: VAPORS OR DIRECT CONTACT MAY CAUSE IRRITATION.
SKIN: CHRONIC CONTACT MAY LEAD TO IRRIT ATION & DERMATITIS. CHRONIC
EXPOSURE TO VAPORS OF HIGH CONCENTRATION MAY CAUSE DERMATITIS. MAY
POSSIBILY BE ABSORBED THROUGH THE SKIN.
Effects of Overexposure:INHALATION: MAY CAUSE IRRITATION OF MUCOUS
MEMBRANES, NOSE & THROAT, HEADACHE, DIZZINESS, NAUSEA, NUMBNESS OF
THE EXTREMITIES & NARCOSIS IN HIGH CONCENTRACTIONS.
Medical Cond Aggravated by Exposure:NONE PROVIDED BY MFR.
======================= First Aid Measures =======================
First Aid:SKIN: WASH THOROUGHLY WITH SOAP & WATER. SEEK MEDICAL ATT'N
IF IRRITATION PERSISTS. EYE: MOVE TO FRESH AIR & IRRIGATE EYES WITH
WATER FOR 15 MIN. IF IRRITATION PERSISTS, SEEK MEDICAL ATT'N. IF
EYE IS STRUCK WITH WIRE, SEEK MEDICAL ATTENTION. INHALATION: MOVE
TO FRESH AIR. IF BREATHING IS DIFFICULT, GIVE OXYGEN. IF NOT
BREATHING, GIVE ARTIFICIAL RESPIRATION. KEEP VICTIM QUIET & WARM.
CALL A POISON CONTROL CENTER OR PHYSICIAN IMMEDIATELY. INGESTION:
DRINK WATER & CALL A POISON CONTROL CENTER OR PHYSICIAN
IMMEDIATELY. NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:=-15.C, 5.F
0 TO 5 DEG F
Lower Limits:1.8
Upper Limits:11.8
Extinguishing Media:FOR SMALL FIRES: USE DRY CHEMICAL, CO2, WATER OR
FOAM EXTINGUISHER. FOR LARGE FIRES: EVACUATE AREA & CALL FIRE
DEPARTMENT IMMEDIATELY.
Fire Fighting Procedures:NONE PROVIDED BY MFR.
Unusual Fire/Explosion Hazard:NONE PROVIDED BY MFR.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA, STOP LEAK IF IT CAN BE DONE
WITHOUT RISK. TAKE UP WITH SAND, EARTH, OR OTHER NON-COMBUSTIBLE
ABSORBING MATERIAL.
Neutralizing Agent:NONE PROVIDED BY MFR.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS & FLAMES;
STORE IN COOL, DRY AREA
Other Precautions:CONTAINERS, EVEN EMPTIES WILL RETAIN RESIDUE & VAPORS
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED CANNISTER RESPIRATOR IN ABSENCE
OF ADEQUATE VENTILATION.
Ventilation:GENERAL MECHANICAL: EXHAUST VENTILATION CAPABLE OF
MAINTAINING EMISSIONS AT THE POINT OF USE BELOW PEL.
Other Protective Equipment:EYE WASH & SHAFETY SHOWER SHOULD BE
AVAILABLE
Work Hygienic Practices:NONE PROVIDED BY MFR.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:=66.1C, 151.F
Decomp Temp:Decomp Text:NONE PROVIDED BY MFR.
Vapor Pres:145 MMHG @ 20 DEG PSI
Vapor Density:2.5(AIR=1)
Spec Gravity:0.90 +/- 0.015
Viscosity:NONE PROVIDED BY MFR.
Evaporation Rate & Reference:5.5 TO 8.0 (BUAC=1)
Solubility in Water:NEGLIBILE
Appearance and Odor:CLEAR LIQUID, ETHER LIKE ODOR
Percent Volatiles by Volume:NONE PROVIDE
Corrosion Rate:NONE PROVIDED BY MFR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS, OXIDIZING MATERIALS, ALKALIS, CHLORINATED INORGANICS (POTASSIUM,
CALCIUM & SODIUM HYPOCHLORITE), COPPER OR COPPER ALLOYS
Stability Condition to Avoid:HEAT, SPARKS & OPEN FLAME.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
HYDROGEN CHLORIDE, SMOKE
Conditions to Avoid Polymerization:WILL NOT OCCUR
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF ACCORDING TO LOCAL, STATE, & FEDERAL
REGULATIONS. EPA HAZARDOUS WASTE ID NUMBER: D-001. EPA HAZARD
WASTE CLASS: IGNITABLE WASTE/TOXIC WASTE.
=================== MSDS Transport Information ===================
Transport Information:CONSUMER COMMODITY ORM-D (FOR GALLONS: CEMENT,
FLAMMABLE LIQUID CONTAINS TETRAHYDROFURAN, METHYL ETHYL KETONE
NA1133)
===================== Regulatory Information =====================
SARA Title III Information:SECTION 313: ACETONE, METHYL ETHYL KETONE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CHO-BOND 360 (CONDUCTIVE EPOXY)
Kit Part:Y
Preparer's Name:DAVID HAAS
CAGE:GO416
CAGE:GO416
CAGE:18565
============= Composition/Information on Ingredients =============
Ingred Name:SILVER (INGREDIENT #1 & 2 ARE USED TO MAKE SILVER-PLATED
COPPER= >90%)
CAS:7440-22-4
RTECS #:VW3500000
Other REC Limits:NONE SPECIFIED.
OSHA PEL:0.01 MG/M3
ACGIH TLV:0.1 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:COPPER (SARA III)
CAS:7440-50-8
RTECS #:GL5325000
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.1MG/M3 FUME/1 DUST
ACGIH TLV:0.2MG/M3 FUME; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:EPOXY RESIN
CAS:25068-38-6
RTECS #:KC2100000
Fraction by Wt: 5-10%
Other REC Limits:NONE SPECIFIED BY M.
Ingred Name:O-CRESYL GLYCIDYL ETHER
CAS:2210-79-9
Fraction by Wt: <2%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE/SKIN:IRRITATION.
PROLONGED/REPEATED EXPOSURE TO LIQ MAY EXERT A DEFATTING/DRYING
ACTION ON SKIN POSSIBLY RESULTING IN DERMATITIS. MAY CAUSE
SENSITIZATION/ALLERGIC REACTIONS. INHALATION:HEATING CAN GENERATE
VAPORS THAT MAY CAUSE RESPIRATORY IRRITATION. INGESTION:HARMFUL.
CHRONIC-ARGYRIA (BLUE-GRAY SKIN)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:RASH, ITCHING, HIVES, SWELLING OF EXTREMITIES.
INHAL:IRRITATION, NAUSEA & HEADACHES. INGEST:HARMFUL. EXCESSIVE OR
PROLONGED CONTACT WITH SILVER OR SILVER COMPOUNDS HAS BEEN KNOWN TO
CAUSE ARGYRIA, A B LUE-GRAY DISCOLORATION OF THE SKIN.
Medical Cond Aggravated by Exposure:SKIN AND/OR EYE DISORDERS.
======================= First Aid Measures =======================
First Aid:INHALATION:REMOVE TO FRESH AIR, PROVIDE CPR/OXYGEN IF NEEDED.
EYE CONTACT:FLUSH WITH WATER FOR 15 MINUTES. GET MEDICAL HELP. SKIN
CONTACT:WASH WITH SOAP AND WATER. GET MED ATTENTION IF SYMPTOMS
PERSIS T. INGESTION:DO NOT INDUCE VOMITING, DRINK 1-2 GLASSES OF
WATER. GET MEDICAL HELP IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point:>200F,>93C
Extinguishing Media:CARBON DIOXIDE, FOAM, DRY CHEMICAL, OR WATER FOG.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD WEAR PROTECTIVE CLOTHING
AND SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:DECOMPOSITION AND COMBUSTION PRODUCTS MAY
BE TOXIC. CLOSED CONTAINERS MAY VIOLENTLY RUPTURE UNDER FIRE
CONDITIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL:ACTIVATE AVAILABLE EXHAUST VENT EQUIP IN
IMMED SPILL AREA. WIPE UP/ABSORB W/VERMICULITE OR SIMILAR MATL.
WASH AREA W/SOAPY WATER TO REMOVE RESIDUE. COLLECT ABSORBED MATL &
WATER RINSES IN APPROP CNTNRS. LGE SPILLS:LIMIT ACCESS
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL DRY LOCATION W/ADEQUATE
VENTILATION. KEEP CONTAINER TIGHTLY SEALED WHEN NOT IN USE. KEEP
AWAY FROM OPEN FLAMES AND HEAT SOURCES.
Other Precautions:AVOID CONTACT WITH SKIN OR EYES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE APPROPRIATE, NIOSH APPROVED PROPERLY FITTED
RESPIRATOR IF EXPOSURES EXCEED TLV VALUES.
Ventilation:MECHANICAL/LOCAL EXHAUST RECOMMENDED TO DRAW VAPORS, MISTS
OR FUMES AWAY FROM WORKERS.
Other Protective Equipment:CHEM RESISTANT APRON, IMPERVIOUS CLTHG.
EMERG EYE WASH & SAFETY SHOWER.
Work Hygienic Practices:WASH HANDS/FACE AFTER HANDLING, BEFORE EATING,
DRINKING, SMOKING. WORK CLTHG SHOULD BE WASHED BEFORE RE-USE.
Supplemental Safety and Health
THIS IS PART A OF A TWO PART KIT. PART B IS HARDNER 20, SEE PART B,
SAME NSN. FOR BEST RESULTS MIX PART A & B IN 1:1 RATIO JUST BEFORE
USE.
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:>1
Appearance and Odor:GRAY-SILVER LIQUID
Percent Volatiles by Volume:NEGLIG
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, OXIDIZERS, BASES;UNCNTRLD MIXING W/ AMINES, ANHYDRIDES,
MERCAPTANS, IMIDAZOLES MAY CAUSE HAZ POLYMERIZATIO
Stability Condition to Avoid:STORAGE IN OPEN CONTAINERS,OPEN
FLAMES,UNCONTROLED EXPOSURE TO HEAT, UNCONTROLED MIXING W/CURING
AGENTS,EXPOS TO INCOMP
Hazardous Decomposition Products:CO, CO2, ALDEHYDES, ACIDS AND OTHER
ORGANIC SUBSTANCES MAY BE FORMED DURING COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE,
AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SODIUM CHROMATE CR 51 INJECTION
CAGE:FO650
CAGE:37940
CAGE:FO650
============= Composition/Information on Ingredients =============
Ingred Name:CHROMIC ACID, DISODIUM SALT; (RADIOACTIVE CHROMIUM, MFR CAS
NUMBER 10039-53-9)
CAS:7775-11-3
RTECS #:GB2955000
Fraction by Wt: 0.001%
OSHA PEL:0.1 MG/M3, C(CR)
ACGIH TLV:0.05 MG/M3 (CR)
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:SODIUM BICARBONATE
CAS:144-55-8
RTECS #:VZ0950000
Fraction by Wt: 0.05%
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 100%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHAL:SODIUM CHROMATE DOES NOT EASILY
BECOME AIRBORNE. NOT EXPECTED TO BE HEALTH HAZ VIA INHALATION.
INGEST: MAY CAUSE ASYMPTOMATIC PHYSIOLOGICAL UPTAKE BY SPECIFIC
TARGET ORGANS OR TISSUES. SKIN: NOT EXPECTED TO PRODUCE ANY ACUTE
ADVERSE HEALTH EFFECTS. EYE: NO ADVERSE EFFECT EXPECTED, BUT MAY
CAUSE (EFTS OF OVEREXP)
Explanation of Carcinogenicity:SODIUM CHROMATE - IARC GROUP 1
Effects of Overexposure:HLTH HAZ: MECHANICAL IRRITATION. CHRONIC:
HEALTH RISKS ASSOCIATED WITH CHRONIC RADIATION EXPOSURE (CANCER,
LEUKEMIA, GENETIC AND TERATOGENIC EFFECTS) ARE BELIEVED TO INVOLVE
LEVELS OF RADIATION EXPOSU RE WHICH ARE MUCH HIGHER THAN THOSE
PERMITTED OCCUPATIONALLY.
Medical Cond Aggravated by Exposure:NO INFORMATION FOUND.
======================= First Aid Measures =======================
First Aid:INHAL:NOT EXPECTED TO REQ FIRST AID MEASURES. INGEST:NOTIFY
RADIA SFTY PERS IMMED. AMT OF MATL INGESTED SHOULD BE ASSESSED &
DOCUMENTED. SKIN:WASH AREA THORO W/SOAP/H*2O/UNTIL NO MORE
RADIOACTIVITY CA N BE REMOVED. ALWAYS BLOT DRY. DO NOT ABRADE SKIN.
NOTIFY RADIA SFTY PERSONNEL. EYE:WASH WITH WATER FOR AT LEAST 15
MIN OR UNTIL NO MORE RADIOACTIVITY CAN BE REMOVED. NOTIFY RADIA
SAFETY PERSONNEL.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE ANY MEANS SUITABLE FOR EXTINGUISHING
SURROUNDING FIRE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED POSITIVE PRESSURE
SCBA AND FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NOT CONSIDERED TO BE AN EXPLOSION HAZARD.
================== Accidental Release Measures ==================
Spill Release Procedures:IF PROD IS RECEIVED IN LEAK CNDTN/ANY LOSS/REL
OF RADIA CONTENTS OCCURS, NOTIFY YOUR RADIA SFTY DEPT &
MALLINCKRODT @ (314) 344-3800. ALL CLEANUP OPERATIONS SHOULD BE
PERFORMED ACCRD TO STD OPERATING PROC (SOPS) ESTABLISHED FOR YOUR
(SUPP DATA)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE @ 15-30C. HNDLG TIME SHOULD BE
KEPT TO MIN, & APPROP SHIELD SHOULD BE USED. HNDLG DEVICES SUCH AS
SYRINGE SHIELDS & TONGS SHOULD BE USED.
Other Precautions:STORAGE & DISPOSAL OF PRODUCT SHOULD BE CONTROLLED IN
MANNER WHICH IS IN COMPLIANCE WITH APPROPRIATE REGULATIONS OF
FEDERAL OR STATE GOVERNMENT AGENCY AUTHORIZED TO LICENSE THE USE OF
THIS RADIONUCLID E.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT EXPECTED TO REQUIRE PERSONAL RESPIRATOR
USAGE. USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE
OF CONCERN .
Ventilation:PROPERLY SEALED CONTAINERS ARE NOT EXPECTED TO REQUIRE ANY
SPECIAL VENTILATION.
Other Protective Equipment:LABCOAT.
Work Hygienic Practices:NO SMOKING, EATING OR DRINKING SHOULD BE
ALLOWED IN ANY AREA WHERE RADIOACTIVE MATERIALS HAVE HANDLED OR
STORED.
Supplemental Safety and Health
SPILL PROC: FACILITY. RADIOACTIVE WASTE SHOULD BE DISPOSED OF ACCORDING
TO SOPS ESTABLISHED BY YOUR RADIATION SAFETY OFFICER. ENSURE
COMPLIANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Melt/Freeze Pt:M.P/F.P Text:32.0F,0.0C
Evaporation Rate & Reference:NO INFORMATION FOUND.
Solubility in Water:SOL IN H*2O
Appearance and Odor:CLEAR, COLORLESS LIQUID. ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NO INFORMATION FOUND.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:MAY EMIT RADIOACTIVE FUMES CONTAINING
CR-51 WHEN HEATED TO DECOMPOSITION.
==================== Disposal Considerations ====================
Waste Disposal Methods:ENSURE COMPLIANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:LACQUER C/N GLOSS PURPLE 27144 ID 786708
Preparer's Name:W. A. ELLISON
CAGE:FO127
CAGE:FO127
CAGE:61196
============= Composition/Information on Ingredients =============
Ingred Name:ISOBUTYL ACETATE (SOLVENT) (LFL 2.0 / UFL 11.0)
CAS:110-19-0
RTECS #:AI4025000
Fraction by Wt: 25%
Other REC Limits:NONE SPECIFIED
OSHA PEL:150 PPM/700 MG/M3
ACGIH TLV:150 PPM/700 MG/M3
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ISOPROPYL ALCOHOL (SOLVENT) (VAPOR PRESSURE 33 MM HG @ 20C)
(LFL 3.0 / UFL 13.0)
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:400 PPM/STEL 500 PPM
ACGIH TLV:400 PPM/STEL 500 PPM
Ingred Name:NITROCELLULOSE (RESIN)
CAS:9004-70-0
RTECS #:QW0970000
Fraction by Wt: 10%
Other REC Limits:NONE SPECIFIED
OSHA PEL:NONE ESTABLISHED
ACGIH TLV:NONE ESTABLISHED
Ingred Name:ISOBUTYL ALCOHOL (SOLVENT) (VAPOR PRESSURE 10 MM HG @ 20C)
(LFL 1.0 / UFL 11.0)
CAS:78-83-1
RTECS #:NP9625000
Fraction by Wt: 15%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TITANIUM DIOXIDE (PIGMENT)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:TOLUENE (SOLVENT) (SARA 313) (VAPOR PRESSURE 22 MM HG @
20C) (LFL 1.7 / UFL 7.1)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: < 5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:VM&P NAPHTHA (SOLVENT) (VAPOR PRESSURE 40 MM HG @ 20C) (LFL
1.0 / UFL 6.0)
CAS:8030-30-6
RTECS #:DE3030000
Fraction by Wt: 10%
Other REC Limits:NONE SPECIFIED
OSHA PEL:300 PPM/STEL 400 PPM
ACGIH TLV:300 PPM/1350 MG/M3
Ingred Name:DI(2-ETHYLHEXYL)PHTHALATE (ADDITIVE) (SARA 313)
CAS:117-81-7
RTECS #:TI0350000
Fraction by Wt: 5%
Other REC Limits:NONE SPECIFIED
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:LIGROINE (PETROLEUM HYDROCARBON MIXTURE)
CAS:8032-32-4
RTECS #:OI6180000
Fraction by Wt: 5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM/525 MG/M3
ACGIH TLV:100 PPM/525 MG/M3
Ingred Name:VOC: 5.93 (GRAMS/LITER)
RTECS #:9999999VO
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INGEST: GASTROINTESTINAL IRRITATION,
NAUSEA AND VOMITING. ASPIRATION OF MATERIAL INTO LUNG: CHEMICAL
PNEUMONITIS. INHAL: NOSE OR THROAT IRRITATION. ACUTE CNS DEPRESSION
W/HEADACHES, DIZZINESS, NAUSEA, CONFUSION. EYE: IRRITATION. SKIN:
IRRITATION AND DEFATTING.
Explanation of Carcinogenicity:NTP AND IARC HAVE DETERMINED THAT THERE
IS SUFFICIENT EVIDENCE OF CARCINOGENICITY OF
DI(2-ETHYLHEXYL)PHTHALATE (DEHP)
Effects of Overexposure:LIVER DAMAGE. PERMANENT BRAIN AND NERVOUS
SYSTEM DAMAGE. KIDNEY-LUNG-SPLEEN DAMAGE. INTENTIONAL MISUSE MAY BE
HARMFUL OR FATAL.
Medical Cond Aggravated by Exposure:NOTE TO PHYSICIAN: ANY TREATMENT
THAT MIGHT BE REQUIRED FOR OVEREXPOSURE SHOULD BE DIRECTED AT THE
CONTROL OF SYMPTOMS AND THE CLINICAL CONDITIONS.
======================= First Aid Measures =======================
First Aid:INGEST: DO NOT INDUCE VOMITING. CALL POISON CENTER, HOSPITAL
EMERGENCY ROOM OR DR IMMED. INHAL: REMOVE TO FRESH AIR IMMED. IF
BREATHING STOPPED, GIVE ARTIFICIAL RESP. KEEP WARM/QUIET-GET MED
AID IMMED . EYE: FLUSH W/WTR-15 MINS, LIFTING LIDS OCCASIONALLY.
GET MED AID. SKIN: REMOVE CONTAMINATED CLOTHING. WASH AFFECTED AREA
WITH SOAP AND WATER. OBTAIN MEDICAL ATTENTION IF IRRITATION
PERSISTS.
===================== Fire Fighting Measures =====================
Flash Point:20.0F,-6.7C
Autoignition Temp:Autoignition Temp Text:572F
Lower Limits:1.0%
Upper Limits:13.0%
Extinguishing Media:NFPA CLASS B FIRE EXTING (CO2-ALL PURPOSE DRY
CHEM-ALCOHOL FOAM) MADE TO EXTING FLAMM LIQ FIRES. POLYMER FOAM-LG
FIRES
Fire Fighting Procedures:USE SCBA. WTR MAY BE INEFFECTIVE-MAY BE USED
TO COOL EXPOSED CNTNR-PREVENT PRESSURE BLDUP/AUTO EXPLOS WHEN
EXPOSED TO EXTREME HEAT. FOG NOZZLES PREFERRED W/WTR
Unusual Fire/Explosion Hazard:DURING EMER CONDITN, OVEREXPOS TO DECOMP
PROD MAY CAUSE HEALTH HAZARD-SYMPTOMS DELAYED. GET MED ATTN.
DANGER] EXTREMELY FLAMMABLE. VAPORS MAY CAUSE FLASH FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:EVAC AREA-ELIM IGNIT SRCS. DIKE/CONTAIN
W/INERT MATL-TRANS LIQ TO COVRD METAL CNTNR. USE NON-SPARK TOOL.
DISPOSE ABSORB DIKING MATL IN COVRD METAL CNTNR. PREVENT CONTAM OF
SEWER-STREAM-GROUNDWATER WIT H SPILLED MATERIAL OR USED ABSORBENT.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 115F (46C). STORE
LARGE QUANTITIES IN COMPLIANCE WITH OSHA 29CFR1910.106
Other Precautions:DO NOT INGEST. CLOSE CNTNR AFTER USE. EMPTY CNTNRS
MUST NOT BE WASHED OR RE-USED FOR ANY PURPOSE. CNTNRS SHOULD BE
GROUNDED/BONDED TO RECEIVING CNTNR. DO NOT WELD-BRAZE-CUT ON EMPTY
CNTNR-NEVER USE PR ESS TO EMPTY. DRUM IS NOT A PRESS VESSEL
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF WELL VENTED RESP NOT REQ. RESTRICTED
VENT-NIOSH CHEM CARTRIDGE RESP REQ. SPRAY-MECH PREFILTER ALSO REQ.
CONFINED-AIR SUPPLY RESP REQ. ABOVE TLV-RESP W/APPROP PROTECT
FACTOR. SEE OSHA 29CFR1910.134 & RESP PROTECT-MANUAL & GUIDELINE
(AIHA)
Ventilation:GEN DILUTION-LOCAL EXHST VENT-SUFFIC VOL/PATTERN TO KEEP
BELOW LOWEST LIMIT. RMV DECOMP PROD COATED WITH THIS PRODUCT
Other Protective Equipment:EYEWASH STATION, SAFETY SHOWER
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:156-302F
Melt/Freeze Pt:M.P/F.P Text:-50F,-46C
Vapor Pres:120 @ 68F
Vapor Density:> THAN AIR
Spec Gravity:1.0
pH:4-7STD
Viscosity:> 200 CST
Evaporation Rate & Reference:SLOWER THAN DIETHYL ETHER
Solubility in Water:SLIGHT IN WATER
Appearance and Odor:LIQUID, SOLVENT ODOR
Percent Volatiles by Volume:74
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS OR ALKALINE MATERIALS.
Stability Condition to Avoid:AVOID EXCESSIVE HEAT (>115F (46C) AND
SOURCES OF IGNITION
Hazardous Decomposition Products:BURNING, WHEN HEATED BY
WELDING/CUTTING WILL PRODUCE SMOKE-CO-CO2. IN ADDITION OXIDES OF
NITROGEN, MAY BE GENERATED.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORD W/FEDERAL-STATE-LOCAL LAWS AND
REGULATIONS. INCINERATE ONLY IN EPA FACILITY. DO NOT INCINERATE
CLOSED CNTNRS. OBSERVE PRECAUTIONS FOR DISPOSAL OF FLAMM MATL. MAY
DISPOSE CONTAMINATED ABSORB IN HAZARDOUS WASTE LANDFILL. RCRA:
D001
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:STOP SOLUTION
Kit Part:Y
CAGE:GO646
CAGE:GO646
============= Composition/Information on Ingredients =============
Ingred Name:SULFURIC ACID (CONFIRMED HUMAN CARCINOGEN BY IARC - GROUP
1) *96-4*
CAS:7664-93-9
RTECS #:WS5600000
Fraction by Wt: <15%
OSHA PEL:1 MG/CUM
ACGIH TLV:1 MG/CUM=IC
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION, SEVERE BURNS,
DAMAGE. SKIN: IRRITATION, BURNS, DERMATITIS. INGESTION: SEVERE
IRRITATION, BURNS TO THROAT/STOMACH/GI TRACT. INHALATION: SEVERE
IRRITATION, IRREVERSIBLE TISSUE DAMAGE T O MEMBRANES OF RESPIRATORY
TRACT. MAY CAUSE DEATH.
Explanation of Carcinogenicity:SEE INGREDIENTS.
Effects of Overexposure:IRRITATION, BLURRED VISION, PAIN, GI
DISTRUBANCES, ULCERATIONS.
Medical Cond Aggravated by Exposure:PREEXISTING SKIN DISORDERS, EYE
PROBLEMS, IMPAIRED RESPIRATORY FUNCTION.
======================= First Aid Measures =======================
First Aid:EYES/SKIN: IMMEDIATELY FLUSH W/PLENTY OF WATER FOR 15 MINS.
INHALATION: REMOVE TO FRESH AIR. INGESTION: DON'T INDUCE VOMITING.
DRINK LARGE QUANTITIES OF WATER TO DILUTE STOMACH CONTENTS. OBTAIN
MEDICA L ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:DRY CHEMICAL, FOAM, CO2.
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING; INCLUDING
HELMET, SCBA IN POSITIVE PRESSURE/PRESSURE DEMAND MODE, PROTECTIVE
CLOTHING & FACE MASK.
Unusual Fire/Explosion Hazard:SULFURIC ACID IS A STRONG OXIDIZER AND
ITS HEAT OF REACTION W/REDUCING AGENTS/COMBUSTIBLES MAY CAUSE
IGNITION.
================== Accidental Release Measures ==================
Spill Release Procedures:GENERAL: DIKE AREA. WEAR PROTECTIVE EQUIPMENT.
AVOID SKIN & EYE CONTACT. AVOID BREATHING FUMES/VAPORS.
LARGE/SMALL: COVER AREA W/SODIUM BICARBONATE & ABSORB W/AN INERT
MATERIAL SUCH AS DIRT/VERMICULIT E. PLACE IN A PROPERLY LABELED,
CLOSED CONTAINER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY, WELL VENTILATED
AREA. KEEP CONTAINER CLOSED & DRY.
Other Precautions:AVOID CONTACT W/SKIN & EYES. AVOID BREATHING
FUMES/VAPORS. CONTACT LENSES SHOULDN'T BE WORN WHEN WORKING W/THIS
MATERIAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NORMALLY NEEDED. WEAR A NIOSH APPROVED FULL
FACEPIECE CHEMICAL CARTRIDGE RESPIRATOR IF PERMISSIBLE LEVELS ARE
EXCEEDED.
Ventilation:APPROPRIATE LOCAL EXHAUST TO KEEP EXPOSURES <REGULATED
LIMITS WHENEVER MISTS/VAPORS ARE GENERATED.
Other Protective Equipment:LAB COAT, APRON, EYEWASH FOUNTAIN, SAFETY
SHOWER
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING & SHOES
BEFORE REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
MSDS INFORMATION IS FOR SULFURIC ACID.
================== Physical/Chemical Properties ==================
pH:-0.4
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR LIQUID W/NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
BASES/ORGANIC MATERIAL/HALOGENS/METAL ACETYLIDES/OXIDES &
HYDRIDES/STRONG OXIDIZING AGENTS/OTHER REACTIVE SUBSTANCES.
Hazardous Decomposition Products:OXIDES OF SULFUR. REACTION
W/CARBONATES-CO2 GAS. REACTION W/CYANIDES & SULFIDES- HYDROGEN
CYANIDE & HYDROGEN SULFIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF WASTE IN A RCRA APPROVED WASTE
DISPOSAL FACILITY IAW/FEDERAL, STATE & LOCAL REGULATIONS. CORROSIVE
LIQUID UN1760. THIS PRODUCT AS PRODUCED IS CONSIDERED A D002
(CORROSIVE) HAZARDOUS WASTE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PRO-SEAL 870 CLASS A PART B
Preparer's Name:AO
CAGE:DO563
CAGE:83574
CAGE:DO563
============= Composition/Information on Ingredients =============
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 10%
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:PHENOL FORMALDEHYDE RESIN (PHENOL POLYMER WITH
FORMALDEHYDE)
CAS:9003-35-4
Fraction by Wt: <5%
Ingred Name:POLYSULFIDE POLYMER
CAS:68611-50-7
Fraction by Wt: 65%
Ingred Name:SILICA
CAS:67762-90-7
Fraction by Wt: <5%
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 10%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:CALCIUM CARBONATE
CAS:1317-65-3
RTECS #:EV9580000
Fraction by Wt: 10%
OSHA PEL:5 MG/M3 RDUST
ACGIH TLV:10 MG/M3 TDUST
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE:IRRIT. SKIN:LOCAL IRRIT. MAY CAUSE
ALLERGIC RASH IN SENSITIZED INDIVIDUALS. INHAL:IRRIT TO
NOSE/THROAT. PRLNGD EXPOS ABOVE TLV MAY CAUSE HEADACHE, FATIGUE,
CONFUSION, DIZZINESS, DROWSINESS, NUMBNE SS & UNCON. PRLNGD EXPOS
CAN CAUSE LIVER & KIDNEY DAMAGE. INGEST:MAY CAUSE NAUSEA, VOMITING,
LIVER & KIDNEY DAMAGE.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH W/LUKE WARM WATER FOR AT LEAST 15 MIN. IF SYMPTOMS
PERSIST, CALL MD. SKIN:WASH W/SOAP & WATER. IF SYMPTOMS PERSIST,
CALL MD. INHAL:REMOVE TO FRESH AIR. IF SYMPTOMS PRESENT, CALL MD.
INGEST:C ALL MD.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:68.0F,20.0C
Lower Limits:SEE INGRED
Upper Limits:SEE INGRED
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM, WATER FOG.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIP . USE WATER TO COOL HEAT EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:HIGH TEMPERATURES MAY CAUSE PRESSURE
BUILDUP IN CLOSED CONTAINERS.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL IGNITION SOURCES. WEAR NIOSH/MSHA
APPRVD AIR-SUPPLIED RESP FOR MAJOR UNVENTILATED SPILL. COVER
W/ABSORBENT. SCOOP INTO CNTNRS. CLEAN UP RESIDUE W/1,1,1
-TRICHLOROETHANE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE BELOW 80F.
Other Precautions:PROD CONTAINS TOXIC CHEMICAL/CHEMICALS SUBJECT TO
REPORTING REQUIREMENTS OF SECTION 313 OF TITLE III OF SUPERFUND
AMENDMENTS & REAUTHORIZATION ACT OF 1986 AND 40 CFR PART 372.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:GEN VENT TO MAINTAIN VAPS BELOW TLV. WHEN APPLYING IN
CONFINED AREAS OR IN OTHER CIRCUMSTANCES LIKELY (SEE SUPP DATA)
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
VENT:TO PRODUCE AIRBORNE LEVELS OF SOLVENT IN EXCESS OF TLV, USE
NIOSH/MSHA APPROVED ORGANIC VAPOR CARTRIDGE RESPIRATOR OR
AIR-SUPPLIED RESPIRATOR. EYE PROT:MAY ADD FULL LENGTH FACESHIELD TO
================== Physical/Chemical Properties ==================
HCC:F3
Vapor Density:SEE INGRED
Spec Gravity:1.41
Evaporation Rate & Reference:SEE INGRED
Solubility in Water:NEGLIGIBLE
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CO*X, SO*2, TRACES OF H*2S.
==================== Disposal Considerations ====================
Waste Disposal Methods:EPA WASTE NO. D-001. DISPOSE OF SPILLAGE IN
COMPLIANCE W/FEDERAL & STATE REGULATIONS.
| 1 | gloves_mandatory |
=======================================================
Product ID: ETCH-KLENZ, 0011
Cage: HO026
Box: 152170
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: HO026
Box: 152170
Cage: 0A782
Box: 152170
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: SEE INGREDIENTS.
Route Of Entry Inds - Inhalation: NO
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE:MAY RSLT IN REDDENING OF SKIN, MOD IRRIT &
DISCOMFORT. INHAL OF MIST (1 PPM) IS IRRIT TO UNACCLIMATED WORKERS, BUT NOT
TO ACCLIMATED WORKERS. EYE CONT PRDCES TEARING, IRRIT & DISCOMFORT.
ACCIDEN TAL INGEST MAY CAUSE SEV BURNS OF MUC MEMBS OF MOUTH, ESOPHAGUS &
STOM. CHRONIC:INGEST MAY PRDCE FATAL (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: HLTH HAZS:EFTS FROM ESOPHAGEAL &/OR
GASTRIC NECROSIS. EYE EXPOS MAY RSLT IN PRLNGD/PERM VISUAL IMPAIRMENT/TOTAL
LOSS OF SIGHT. CHRONIC SKIN EXPOS CAN YIELD ULCERATION, DERM & POSS
SCARRING. CHRONIC IN HAL OF SPRAY MIST MAY PRDCE IRRIT & POSS INCRD
SUSCEPTABILITY TO RESP DISEASE. WARNING:PROD CNTNS DIOXANE &
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: INHAL:REMOVE TO FRESH AIR. IF BRTHG HAS STOPPED, ARTF RESP SHOULD BE
STARTED. OXYG MAY BE ADMIN, IF READILY AVAIL. EYE:IMMED FLUSH W/LG AMTS OF
WATER FOR @ LST 15 MIN, HOLDING LIDS APART TO ENSURE FLU SHING OF ENTIRE
SURF. WASHING W/IN 1 MIN IS ESSNTL TO ACHIEVE MAX EFTIVENESS. SEEK MED ATTN
IMMED. SKIN:IMMED WASH CONTAM SKIN W/PLENTY OF WATER. THIS MAY BE FOLLOWED
W/RINSE W/SODIUM
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: CONTAIN SPILLS. SMALL QUANTITIES MAY BE FLUSHED WITH
COPIOUS QUANTITIES OF WATER. IN CASE OF LARGER AMOUNTS, CONTAIN LIQUID. USE
LIMESTONE, LIME OR SODA ASH TO CAUTIOUSLY NEUTRALIZE.
Neutralizing Agent: ADD SLOWLY TO SOLN OF SODA ASH & SLAKED LIME W/STIRRING
THEN FLUSH TO (SUPDAT)
Waste Disposal Methods: DISPOSE OF IN ACCORDANCE WITH ALL FEDERAL, STATE &
LOCAL REGULATIONS CONCERNING HEALTH AND POLLUTION. DISPOSE VIA APPROVED
CHEMICAL WASTE DISPOSAL METHODS, IF REGULATIONS PERMIT.
Handling And Storage Precautions: NONE SPECIFIED BY MANUFACTURER.
Other Precautions: IF UE (USE EXEMPTION) APPEARS UNDER UPPER % LIM, END USERS
ARE EXEMPT FROM NOTIFICATION BECAUSE PROD IS USED & LBLED FOR ROUTINE
JANITORIAL WORK/PROD IS USED & LBLED FOR FACILITY GROUNDS MAINT (SUCH A S
FERTILIZER & HERBICIDES)/PROD (SUPDAT)
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: NON-FLAMMABLE
Extinguishing Media: FOAM, "ALCOHOL" FOAM, CO*2, DRY CHEMICAL, WATER SPRAY.
Fire Fighting Procedures: WEAR NIOSH APPRVD SCBA & FULL PROT EQUIP (FP N).
PHOSPHORIC ACID IS NON-FLAM, HOWEVER, IT CAN REACT W/METALS TO LIBERATE
HYDROGEN, FLAM GAS. WATER SPRAY(SUPDAT)
Unusual Fire/Explosion Hazard: A LATENT FIRE OR EXPLOSIVE HAZARD WHEN IN
CONTACT WITH METALS DUE TO THE GENERATION OF HYDROGEN GAS.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NIOSH APPRVD RESP PROT REQ IN ABSENCE OF PROPER ENVIRON
CTL. FOR EMERS, SCBA/FULL FACE RESP AS APPRVD BY NIOSH IS REC. (IDLH
LEVEL-(PHOSPHORIC ACID) NOT EST, ETHYLENE GLYCOL MONOBUTYL ETHER=700 PPM).
REC RESP SELECTIONS:FOR EXPOS (SUPDAT)
Ventilation: GOOD INDUST HYGIENE PRACT DICTATES THAT WORK AREA SHOULD BE
ISOLATED & CNTND & PROVIDED W/ADEQ LOC EXHST VENT
Other Protective Equipment: ANSI APPROVED EMERGENCY EYE WASH AND DELUGE SHOWER
(FP N).
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: USERS OF "L" VERSION CONSULT "LR" VERSION FOR
ADDNL INFO (FP N). PH @ 100%:2. FIRE FIGHT PROC:MAY BE EFTIVE IN ABSORBING
GAS. NEUT AGENT:SEWER W/LG VOLS OF WATER. OTHER PRECS:IS USED & LBLED FOR
MAINT MOTOR VEHICLES. RESP PROT:</= 50 MG/M3-HIEPF/SAF/SCBAF,-< 2000
MG/M3:SAF:PD,PP,CF.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: 210F,99C
Vapor Pres: 18
Vapor Density: 0.6
Spec Gravity: 1.110 (H*2O=1)
PH: SUPDAT
Evaporation Rate & Reference: 0.1 (BU AC=1)
Solubility in Water: COMPLETE
Appearance and Odor: TRANSPARENT, WATER WHITE; ORANGE ODOR.
Percent Volatiles by Volume: 79
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: SULFIDES, SULFITES, STRONG ALKALIS. PRLNGD CONT W/AL MAY
CAUSE DARKENING. METALS:CR, TIN, GALVANIZED & NICKEL PLATE.
Hazardous Decomposition Products: INCOMPLETE COMBUSTION MAY RESULT IN CARBON
MONOXIDE AND TOXIC FUMES OF OXIDES OF PHOSPHOROUS.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: ETCH-KLENZ, 0011
Cage: HO026
Assigned IND: Y
Company Name: CHEMSEARCH DIV NCH CORP
PO Box: 152170
Zipcode: 75015
Label Required IND: Y
Date Of Label Review: 10/08/1996
Status Code: C
Label Date: 10/08/1996
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Severe
Contact Hazard: Severe
Fire Hazard: Moderate
Reactivity Hazard: None
Hazard And Precautions: COMBUSTIBLE. ACUTE:MAY RSLT IN REDDENING OF SKIN, MOD
IRRIT & DISCOMFORT. EYE CONT PRDCES TEARING, IRRIT & DISCOMFORT.
INGEST:MAY CAUSE SEV BURNS OF MUC MEMBS OF MOUTH, ESOPHAGUS & STOM.
CHRONIC:ANIMA L STUDIES CLEARLY DEMONSTRATED DOSE-RELATED ADVERSE EFFECTS ON
CNS, BLOOD-FORMING TISS, BLOOD, KIDNEYS & LIVER, ASSOC W/ADMIN OF
ETHYLENE GLYCOL MONOBUTYL ETHER (FP N). INGEST:MAY PRDCE FATAL EFTS FRO M
THROAT &/OR GASTRIC NECROSIS. EYES:IMPAIRMENT/LOSS OF SIGHT.
SKIN:SCARRING, ULCERATION, DERM. INHAL:IRRIT, SUSCEPTIBILITY TO RESP DISEASE.
CNTNS INGS IN TRACE AMTS WHICH MAY CAUSE CANCER.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:135-98 OYSTER WHITE, PACON SUPREME (SUPDAT)
CAGE:EO376
CAGE:EO376
CAGE:85520
============= Composition/Information on Ingredients =============
Ingred Name:ETHYLENE GLYCOL (SARA 313) (CERCLA). % (WT):1.10-2.59
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: SEE ING
OSHA PEL:N/K
ACGIH TLV:C 50 PPM, VAPOR
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:PIGMENTS
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:VOLATILE ORGANIC COMPOUND:0.68 TO 1.02
RTECS #:9999999VO
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPDAT:OPERATIONS IN WHICH THESE PRODUCTS MAY BECOME
AIRBORNE IN FORM OF VAPOR OR DUST.
RTECS #:9999999ZZ
Ingred Name:VENT:RESP TO PVNT OVEREXP. PROVIDE GEN DILUTION/LOC EXHAUST
VENT IN FOL & PATTERN TO KEEP TLV OF MOST HAZ INGRED (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5:BELOW ACCEPTABLE LIM. LEL IN FIRE & EXPLO HAZ DATA
SECTION BELOW STATED LIM & TO REMOVE DECOMP PRODS DURING(ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6:WELDING OR FLAME CUTTING ON SURFACES COATED WITH
THESE PRODUCTS.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:BASED ON PRESENCE OF COMPONENT (1),
THESE PRODUCTS CAN BE IRRITATING TO THE EYES. CHRONIC:REPORTS HAVE
ASSOC REPEATED & PROLONGED OCCUP OVEREXPOS TO SOLVS W/PERM BRAIN &
NERV SYS DMG. INTENTIONAL MISU SE BY DELIBERATELY CONC & INHALING
CONTENTS MAY BE HARMFUL/FATAL. DO NOT BREATHE VAPORS OR SPRAY MIST.
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:WEAR AN APPROP, PROPERLY FITTED RESP
(NIOSH/MSHA APPRVD) DURING & AFTER APPLIC UNLESS AIR MONITORING
DEMONSTRATES VAP/MIST LEV ARE BELOW APPLIC LIMS. FOLLOW RESP MFR'S
DIRECTIONS FOR RESP USE .
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH W/LUKE WARM WATER FOR @ LEAST 15 MINS. SEEK PHYS
IMMED. SKIN:FLUSH WASH W/COPIOUS AMTS OF LUKE WARM WATER. REMOVE
CONTAMD CLTHG PROMPTLY. CONT PHYS IMMED. INHAL:REMOVE EXPOS
INDIVIDUAL TO FR ESH AIR. RESTORE BRTHG IF REQD. CONT PHYS IMMED.
INGEST:RINSE MOUTH IMMED. GIVE EXPOS INDIVIDUAL 6-8 OUNCES OF LIQ.
(NEVER GIVE ANYTHING BY MOUTH TO UNCON PERSON). DO NOT INDUCE VOMIT
UNLESS (SUPDAT)
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP .
CNTNRS EXPOS TO INTENSE HEAT FROM FIRES SHOULD BE COOLED W/WATER TO
PVNT VAP PRESS BUILDUP WHICH COULD (SUPDAT)
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:NONE SPECIFIED BY MANUFACTURER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP FROM FREEZING. DO NOT STORE ABOVE
120F. DO NOT TAKE INTERNALLY. CLOSE CONTAINER AFTER EACH USE. KEEP
OUT OF THE REACH OF CHILDREN.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IN OUTDOOR/OPEN AREAS, USE (NIOSH/MSHA APPRVD)
MECH FILTER RESP TO REMOVE SOLID AIRBORNE PARTICLES OF OVERSPRAY
DURING SPRAY APPLIC. IN RESTRICTED VENT AREAS, USE (NIOSH/MSHA
APPRVD) CHEM MECH FILTERS DESIGNED TO REMOVE COMBINATION (SUPDAT)
Ventilation:USE VENT AS REQD TO CTL VAP CONC. AVOID PRLNGD/RPTD BRTHG
OF VAPS. IF EXPOS EXCEEDS TLV, USE NIOSH/MSHA APPRVD (ING 5)
Other Protective Equipment:APRON. ANSI APPRVD EMERGENCY EYE WASH &
DELUGE SHOWER .
Work Hygienic Practices:WASH HANDS THORO BEFORE EATING & USING
WASHROOM. REMOVE CONTAMD CLTHG IMMED & DO NOT WEAR UNTIL IT HAS
BEEN LAUNDERED.
Supplemental Safety and Health
MFR TRADE NAME/PART NO:INTERIOR VINYL FLAT WALL PAINT. %
VOLAT:63.85-72.97. FIRE FIGHT PROC:RSLT IN CNTNR RUPTURE. FIRST AID
PROC:ADVISED BY PHYS. CONT PHYS IMMED. RESP PROT:OF PARTICULATE &
GAS & VAP . IN CONFINED AREAS, USE (NIOSH/MSHA APPRVD) AIR LINE
TYPE RESPS/HOODS. RESP PROT MAY ALSO BE NEC IN LATER MFG (ING 4)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>212F,>100C
Vapor Pres:17 @ 68F
Vapor Density:HVR/AIR
Spec Gravity:1.31-1.39
Evaporation Rate & Reference:SLOWER THAN BUTYL ACETATE
Solubility in Water:NOT KNOWN
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:SUPDAT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
THESE PRODS ARE INCOMPAT WITH STRONG ACIDS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:MAY PRDCE HAZ FUMES WHEN HEATED TO
DECOMP AS IN WELDING. FUMES MAY CNTN CO, CO*2 & OXIDES OF NITROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT FLUSH TO SEWER, WATERSHED OR WATERWAY.
DISPOSE OF THESE PRODUCTS IN ACCORDANCE WITH APPLICABLE LOCAL,
COUNTY, STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:153 7950 FLEXICOLOR BLEACH III REPLENISHER, PART A
Kit Part:Y
CAGE:19139
CAGE:19139
CAGE:5K871
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 70-75%
Other REC Limits:NONE RECOMMENDED
Ingred Name:AMMONIUM ACETATE (CERCLA)
CAS:631-61-8
RTECS #:AF3675000
Fraction by Wt: 10-15%
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:AMMONIUM BROMIDE
CAS:12124-97-9
RTECS #:BO9170000
Fraction by Wt: 10-15%
Other REC Limits:NONE RECOMMENDED
Ingred Name:ACETIC ACID (CERCLA)
CAS:64-19-7
RTECS #:AF1225000
Fraction by Wt: 5-10%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 PPM
ACGIH TLV:10 PPM/15 STEL; 9596
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT): NOT GIVEN
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EXPECTED TO BE A LOW INHALATION HAZARD
FOR RECOMMENDED HANDLING. VAPOR MAY BE IRRITATING. CAUSES EYE
IRRITATION. LOW SKIN CONTACT HAZARD FOR RECOMMENDED HANDLING.
EXPECTED TO BE A LOW INGESTION HAZARD .
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:EYE IRRITATION, RESPIRATORY TRACT IRRITATION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION: IF SYMPTOMATIC, MOVE TO FRESH AIR. GET MEDICAL
ATTENTION IF SYMPTOMS PERSIST. EYES: WASH OUT IMMEDIATELY WITH
WATER. GET MEDICAL ATTENTION IF SYMPTOMS OCCUR. SKIN: WASH WITH
SOAP AND WATER . GET MEDICAL ATTENTION IF SYMPTOMS OCCUR.
INGESTION: DRINK 1-2 GLASSES OF WATER. SEEK MEDICAL ATTENTION.
NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL, ALCOHOL
FOAM
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY PRODUCE
HAZARDOUS DECOMPOSTION PRODUCTS.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH TO SEWER IF ALLOWABLE WITH LARGE AMOUNTS
OF WATER. OTHERWISE, ABSORB SPILL WITH VERMICULITE OR OTHER INERT
MATERIAL, THEN PLACE IN A CONTAINER FOR CHEMICAL WASTE. CLEAN
SURFACE TO REMOVE RESIDUA L CONTAMINATION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTACT WITH EYES. AVOID
PROLONGED OR REPEATED CONTACT WITH SKIN. USE WITH ADEQUATE
VENTILATION. KEEP CONTAINER TIGHTLY CLOSED.
Other Precautions:KEEP AWAY FROM INCOMPATIBLE MATERIALS. KEEP FROM
CONTACT WITH OXIDIZING MATERIALS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED. A FULL-FACE
POSITIVE-PRESSURE AIR-SUPPLIED RESPIRATOR MUST BE WORN IF HAZARDOUS
DECOMPOSITION PRODUCTS ARE LIKELY TO BE RELEASED OR HAVE BEEN
RELEASED.
Ventilation:GOOD GENERAL VENTILATION, TYPICALLY 10 AIR CHANGES PER
HOUR, SHOULD BE USED. RATES SHOULD MATCH CONDITIONS.
Other Protective Equipment:CHEMICAL RESISTANT CLOTHING AS NECESSARY TO
PREVENT SKIN CONTACT. AN EMERGENCY EYEWASH AND SHOWER SHOULD BE
AVAILABLE.
Work Hygienic Practices:WASH HANDS THOROUGHLY WITH SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES.
Supplemental Safety and Health
REMOVE AND WASH CONTAMINATED CLOTHING BEFORE REUSE. KEY1:C3.
================== Physical/Chemical Properties ==================
HCC:C3
Boiling Pt:B.P. Text:>212F,>100C
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Vapor Pres:18
Vapor Density:0.6
Spec Gravity:1.09
pH:4.9
Evaporation Rate & Reference:NOT GIVEN
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS LIQUID, STRONG VINEGAR ODOR
Percent Volatiles by Volume:70-75%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
BASES, SODIUM HYPOCHLORITE (BLEACH), STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
OXIDES OF NITROGEN, HYDROGEN BROMIDE, AMMONIA, CHLORAMINE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT OR DISPOSAL MAY BE SUBJECT
TO NATIONAL, STATE OR LOCAL LAWS. MAY REQUIRE NEUTRALIZATION IF PH
< 2.0 OR PH > 12.5. DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE ANDLOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:O-C-265
CAGE:KO791
CAGE:78918
CAGE:KO791
============= Composition/Information on Ingredients =============
Ingred Name:ETHYL ALCOHOL (ETHANOL)
CAS:64-17-5
RTECS #:KQ6300000
Fraction by Wt: 92.4%
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM; 9192
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 7.6%
===================== Hazards Identification =====================
Effects of Overexposure:IRRITATION OF EYES & RESPIRATORY
TRACT;HEADACHE,DIZZINESS,DROWSINESS,FATIGUE,NAUSEA,TREMOR,NARCOSIS
======================= First Aid Measures =======================
First Aid:IRRIGATE EYES WITH WATER.STOMACH WASH,IF SWALLOWED,FOLLOWED
BY SALINE CATHARSIS.REMOVE PATIENT FROM EXPOSURE
===================== Fire Fighting Measures =====================
Flash Point:70F TOC.
Lower Limits:3.3
Upper Limits:19.0
Extinguishing Media:DRY CHEMICAL,FOAM,OR CARBON DIOXIDE.WATER SPRAY
INEFFECTIVE.
Fire Fighting Procedures:WATER SHOULD BE USED TO KEEP FIRE EXPOSED
CONTAINERS COOL
Unusual Fire/Explosion Hazard:N.A.
================== Accidental Release Measures ==================
Spill Release Procedures:KEEP HEAT OR IGNITION SOURCES AWAY.SMALL
AMOUNTS MAY BE FLUSHED AWAY.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM OXIDIZING AGENTS;KEEP
AWAY FROM IGNITION SOURCES;USE ADEQUATE VENTILATION.PROTECT
CONTAINERS AGAINST PHYSICAL DAMAGE.
Other Precautions:ELIMINATE STATIC ELECTRICITY.DO NOT STORE WITH
PERCHLORATES,PEROXIDES,CHROMIC ACID & NITRIC ACID.WEAR CHEMICAL
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SELF CONTAINED BREATHING APPARATUS OR CHEMICAL
CARTRIDGE RESPIRATOR
Ventilation:AS REQUIRED TO CONTROL TLV IN AIR.
Other Protective Equipment:RUBBER APRONS,RUBBER BOOTS,SAFETY EYE BATH
Supplemental Safety and Health
THE ITEM IS 190 PROOF ETHYL ALCOHOL
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:=78.3C, 173.F
Vapor Pres:40
Vapor Density:1.59
Spec Gravity:0.8158
Evaporation Rate & Reference:2.7-BUTYL ACETATE
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS LIQUID,MILD ALCOHOLIC ODOR.
Percent Volatiles by Volume:99.9
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIALS,PEROXIDES,CHROMIC ACID,NITRIC ACID
Stability Condition to Avoid:KEEP AWAY FROM HEAT OR IGNITION SOURCES.
Hazardous Decomposition Products:CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:SPRAY INTO A FURNACE UNDER CONTROLLED
CONDITIONS.INCINERATION WILL BECOME EASIER BY MIXING WITH A NONE
FLAMMABLE SOLVENT
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:372-378 MINERAL OIL
Preparer's Name:DICK KARBO
CAGE:KMADD
CAGE:KMADD
============= Composition/Information on Ingredients =============
Ingred Name:COPPER COMPOUND
Fraction by Wt: 5%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PROLONGED CONTACT W/SKIN/EYES CAN
CAUSE IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION
======================= First Aid Measures =======================
First Aid:EYES: FLUSH IMMEDIATELY W/WATER. SKIN: WASH AFFECTED AREA
W/SOAP & WATER. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:>200F
Extinguishing Media:FOAM, CO2, DRY CHEMICAL
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL: WIPE UP & STORE WIPERS IN UNDERWRITERS
APPROVED CONTAINERS. LARGE: SCOOP MATERIAL INTO SEALABLE
CONTAINERS. WIPE UP REMAINDER & STORE WIPERS IN UNDERWRITERS
APPROVED CONTAINERS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN CLOSED CONTAINERS.
Other Precautions:AVOID CONTACT W/SKIN, EYES & CLOTHING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AS REQUIRED
Ventilation:LOCAL EXHAUST
Work Hygienic Practices:WASH AFTER USE. REMOVE/LAUNDER CONTAMINATED
CLOTHING BEFORE REUSE. DON'T CONSUME FOOD/BEVERAGE WHERE PRODUCT IS
USED.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:470-610F
Evaporation Rate & Reference:SLOWER THAN WATER
Solubility in Water:INSOLUBLE
Appearance and Odor:OILY
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/FEDERAL, STATE &
LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:5825 ULTRA-HIDE LATEX LOW LUSTRE ENAMEL
CAGE:01PD6
CAGE:01PD6
============= Composition/Information on Ingredients =============
Ingred Name:CLAY (KAOLIN), ALUMINUM SILICATE
CAS:1332-58-7
RTECS #:GF1670500
Fraction by Wt: 1-5%
ACGIH TLV:10 MG/CUM TOTAL DUST
Ingred Name:GLYCOL ETHERS, DIETHYLENE GLYCOL, 2,2-OXYBISETHANOL
CAS:111-46-6
RTECS #:ID5950000
Fraction by Wt: 1-5%
Ingred Name:STYRENE ACRYLIC COPOLYMER
Fraction by Wt: 1-5%
Ingred Name:1,2-PROPANEDIOL (PROPYLENE GLYCOL)
CAS:57-55-6
RTECS #:TY2000000
Fraction by Wt: 1-5%
Ingred Name:TITANIUM DIOXIDE, TIO2 (SUSPECTED ANIMAL CARCINOGEN, IARC
GROUP 3) *95-4*
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 10-20%
OSHA PEL:15 MG/CUM
ACGIH TLV:10 MG/CUM (DUST)
Ingred Name:VINYL ACRYLIC RESIN *95-4*
CAS:25067-01-0
Fraction by Wt: 10-20%
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 50-60%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: IRRITATION OF RESPIRATORY
TRACT. SKIN: IRRITATION. PROLONGED/REPEATED CONTACT CAN CAUSE
DERMATITIS. MAY BE ABSORBED. EYES: IRRITATION. INGESTION: LARGER
AMOUNTS COULD CAUSE SERIOUS INJURY. (SEE SUPP)
Explanation of Carcinogenicity:NONE
Effects of Overexposure:DIZZINESS, LIGHTHEADEDNESS, HEADACHE, NAUSEA,
IRRITATION.
Medical Cond Aggravated by Exposure:PRE-EXISTING EYE, SKIN,
RESPIRATORY, KIDNEY, LIVER & NERVOUS SYSTEM DISORDERS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE & SUPPORT CONTINUED
BREATHING. HAVE TRAINED PERSON GIVE OXYGEN IF NECESSARY. SKIN: WASH
OFF QUICKLY W/PLENTY OF WATER, THEN SOAP & WATER. EYES: FLUSH
IMMEDIATE LY W/LARGE AMOUNTS OF WATER FOR 15 MINS. OBTAIN MEDICAL
ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:>200F
Extinguishing Media:DRY CHEMICAL/FOAM
Fire Fighting Procedures:WATER MAY BE USED TO COOL & PROTECT EXPOSED
CONTAINERS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY BURST IF EXPOSED TO
EXTREME HEAT/FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:MAY BE COLLECTED W/ABSORBENT MATERIALS.
VENTILATE AREA.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE <100F. KEEP FROM FREEZING. USE
W/ADEQUATE VENTILATION. KEEP CONTAINERS TIGHTLY CLOSED & UPRIGHT
WHEN NOT IN USE.
Other Precautions:IF SANDING IS DONE, WEAR A DUST MASK TO AVOID
BREATHING OF SANDING DUST. DON'T TAKE INTERNALLY. KEEP OUT OF REACH
OF CHILDREN. AVOID CONTACT W/SKIN, EYES & BREATHING OF VAPORS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE ONLY NIOSH/MSHA APPROVED RESPIRATORS IF
CONCENTRATIONS ARE BELOW APPLICABLE STANDARDS.
Ventilation:DILUTION/LOCAL EXHAUST VENTILATION TO PREVENT BUILDUP OF
VAPORS.
Other Protective Equipment:EYE WASH, SAFETY SHOWER
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH THOROUGHLY AFTER HANDLING, EATING/SMOKING.
Supplemental Safety and Health
HEALTH HAZARDS CONT'D: PRODUCTS IN THIS SERIES CONTAIN ETHYLENE GLYCOL
WHEN TINTED W/DRAMATONE. ETHYLENE GLYCOL CAN CAUSE SEVERE KIDNEY
DAMAGE WHEN INGESTED.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F
Percent Volatiles by Volume:68.4
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS
Stability Condition to Avoid:EXTREME HEAT, FIRE, ELEVATED TEMPERATURES,
FREEZING.
Hazardous Decomposition Products:CO, CO2
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS. AVOID DISCHARGE TO NATURAL WATERS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:173 8608 COLOREDGE 1525 BLACK TONER
CAGE:S5612
CAGE:S5612
CAGE:19139
============= Composition/Information on Ingredients =============
Ingred Name:BISPHENOL A PROPYLENE OXIDE FUMARATE (POLYESTER RESIN)
CAS:39382-25-7
Fraction by Wt: 85-95%
Other REC Limits:NONE SPECIFIED
Ingred Name:SALICYLIC ACID CHELATE
CAS:72869-85-3
Fraction by Wt: <4%
Other REC Limits:NONE SPECIFIED
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: 1-5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3; 9192
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: LOW HAZARD FOR RECOMMENDED
HANDLING. MATERIAL IS A FINELY DIVIDED SOLID - AVOID BREATHING OF
DUST. EYE: MAY LEAD TO TRANSIENT IRRITATION. SKIN: LOW HAZARD.
INGESTION: EXPECTED TO BE A LOW HAZARD ACCORDING TO KODAK. CHRONIC
OVEREXPOSURE TO CARBON BLACK DUST CAN CAUSE PNEUMOCONIOSIS.
Explanation of Carcinogenicity:THE COMPONENTS OF THIS PRODUCT HAVE NOT
SHOWN ANY EVIDENCE OF BEING CARCINOGENIC.
Effects of Overexposure:SLIGHT IRRITATION OF EYES/SKIN/RESPIRATORY
SYSTEM.
Medical Cond Aggravated by Exposure:PERSONS WITH A SKIN DISORDER SHOULD
USE CAUTION WHEN HANDLING OR USING THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR & RESTORE BREATHING IF
NECESSARY. GET MEDICAL ATTENTION. EYE/SKIN: IMMEDIATELY FLUSH WITH
WATER FOR 15 MINUTES WHILE HOLDING EYELIDS OPEN. GET MEDICAL
ATTENTION. INGEST ION: DRINK WATER TO DILUTE. NOTHING BY MOUTH IF
UNCONSCIOUS. CALL PHYSICIAN
===================== Fire Fighting Measures =====================
Extinguishing Media:USE WATER SPRAY, CARBON DIOXIDE, OR DRY CHEMICAL AS
APPROPRIATE FOR SURROUNDINGS.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. EVACUATE AREA. COOL
FIRE EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS. FINE POWDER DUST CAN
CREATE AN EXPLOSION HAZARD.
================== Accidental Release Measures ==================
Spill Release Procedures:MINOR: SWEEP MATERIAL ONTO PAPER. PLACE IN
FIBER CARTON OR OTHER APPROPRIATE DISPOSAL CONTAINERS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, VENTILATED WORK AREA.
KEEP CONTAINERS CLOSED WHEN NOT IN USE. AVOID CONTACT WITH OR
BREATHING OF DUST.
Other Precautions:GENERAL: LOW HAZARD LEVEL. IF MATERIAL GETS IN THE
EYE, FLUSH WITH PLENTY OF WATER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR FOR HANDLING
DUST PARTICULATES IF PROLONGED CONTACT WITH MATERIAL.
Ventilation:ADEQUATE ROOM VENTILATION.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:DO NOT TAKE INTERNALLY. AVOID SKIN CONTACT.
WASH SKIN AFTER USING PRODUCT. DO NOT EAT, DRINK OR SMOKE IN WORK
AREA.
Supplemental Safety and Health
COMBUSTIBLE DUST. AVOID CREATING DUST EXPLOSION CONDITIONS. KODAK
HAZARD CODES: (R1,S1,F1,C0)
================== Physical/Chemical Properties ==================
HCC:N1
Vapor Pres:NEGLIGIBLE
Spec Gravity:1.0-1.2
Solubility in Water:NEGLIGIBLE
Appearance and Odor:FINE BLACK POWDER; SLIGHT ODOR
Percent Volatiles by Volume:NIL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE AND
OTHER HYDROCARBON COMPOUNDS DURING COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE
LOCAL, STATE AND FEDERAL LAWS AND REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TW-25B HIGH-TECH LUBRICANT, TW25B-1SY12
Resp. Party Other MSDS Num.:211B
CAGE:0BAN7
Contract Num:SP0450-99-M-B212
CAGE:0BAN7
============= Composition/Information on Ingredients =============
Ingred Name:NONHAZARDOUS INGREDIENTS (SYNTHETIC OILS (ORGANIC ESTERS) &
HIGHLY REFINED MINERAL OILS)
Other REC Limits:NONE RECOMMENDED
ACGIH TLV:5 MG/M3 (OIL MIST)
Ingred Name:HAZARDOUS INGREDIENTS (CALCIUM SULFONATE/CARBOXYLATE
COMPLEX IN HIGHLY REFINED MINERAL OIL AND TRICRESYL PHOSPHATE)
Other REC Limits:NONE RECOMMENDED
ACGIH TLV:5 MG/M3 (OIL MIST)
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Effects of Overexposure:NONE KNOWN
Medical Cond Aggravated by Exposure:NONE KNOWN
======================= First Aid Measures =======================
First Aid:IF ANY QUANTITY IS INGESTED, CONTACT PHYSICIAN. DO NOT INDUCE
VOMTING, DRINK PLENTY OF WATER.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:=246.1C, 475.F
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:USE CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:USE AIR PACK.
Unusual Fire/Explosion Hazard:INHALATION OF THERMAL DECOMPOSITION
PRODUCTS OF FLUOROCARBONS MUST BE AVOIDED FOR THE SAME REASONS THAT
APPLY TO ALL COMBUSTIBLE MATERIALS.
================== Accidental Release Measures ==================
Spill Release Procedures:SALVAGE UNCONTAMINATED MATERIAL. OTHERWISE
DISPOSE OF AS WASTE OIL. DO NOT INCINERATE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NO SPECIAL REQUIREMENT
Ventilation:IF SPRAYING
Other Protective Equipment:AVOID INGESTION, WASH SKIN OR CLOTHING WITH
DETERGENT.
Work Hygienic Practices:KEEP AREA CLEAN.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:V6
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:NOT GIVEN
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Decomp Temp:Decomp Text:NOT GIVEN
Vapor Pres:NOT GIVEN
Vapor Density:NOT GIVEN
Spec Gravity:1.48
Evaporation Rate & Reference:NOT GIVEN
Solubility in Water:LONG TERM-NEGLIGIBLE
Appearance and Odor:OFF WHITE OIL - SWEET ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG ACIDS, STRONG BASES
Stability Condition to Avoid:SUSTAINED TEMPERATURES ABOVE 600F
Hazardous Decomposition Products:PRODUCTS OF COMBUSTION ARE TOXIC. MAY
FORM HYDROGEN FLUORIDE AND/OR PHOSPHORUS OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:REMOVE TO APPROVED LUBRICANT RECOVERY PROCEDURE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CERAMIC COATING
CAGE:0DCP7
CAGE:0DCP7
============= Composition/Information on Ingredients =============
Ingred Name:SILICA
ACGIH TLV:0.5 MG/M3 (MFR)
Ingred Name:ORGANIC PIGMENTS (LEAD AND CHROMATE FREE)
ACGIH TLV:5 MG/M3 (MFR)
Ingred Name:POTASSIUM DICHROMATE
CAS:7778-50-9
RTECS #:HX7680000
OSHA PEL:C,0.1 MG/M3 CRO3
ACGIH TLV:0.5 MG CR/M3; 9293
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:SILACEOUS MATERIALS
ACGIH TLV:0.5 TO 1 MG/M3
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:PROD IS MOD ALKALINE MATL. HIGHLY
ALKALINE MATLS CONSIDERED CORR TO ALL TISS. MIST:ACUTE:SHORTNESS OF
BREATH, COUGHING, TIGHTNESS IN CHEST. CHRONIC:PRLNG/RPTD INHAL IN
EXCESS OF LIMS MAY CAUSE INJURY TO LUNGS. LIQ:ACUTE:MILD BURNING
ON CNTCTED SKIN. CHRONIC:EYES:SEV PAIN & BURNING. SKIN:REDNESS &
PAIN @ EXPOSED SITES.
Explanation of Carcinogenicity:POTASSIUM DICHROMATE IS LISTED IN THE
RTECS AS AN IARC GROUP 1 CARCINOGEN.
Effects of Overexposure:MIST:SHORTNESS OF BREATH, COUGHING, TIGHTNESS
IN CHEST. LIQUID:MILD BURNING ON CONTACTED SKIN.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE SUBJECT TO FRESH AIR. EYE:IMMED WASH W/PLENTY OF
WATER FOR AT LEAST 15 MINUTES & SEE MD IF IRRIT PERSISTS. SKIN:WASH
THORO W/SOAP & WATER. REMOVE & WASH CONTAM CLTHG BEFORE REUSE.
INGEST: DO NOT INDUCE VOMIT. INTRODUCE LARGE QUANTITIES OF WATER.
CALL MD IMMED.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:SPILL AREA MAY BE SLIPPERY. KEEP ALL
UNNECESSARY PERSONNEL AWAY. USE CARE TO AVOID FALLING DOWN. CLEAN
UP AREA BY ABSORBING MATERIAL (AVOID DUSTING).
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE PROT EQUIP & CLTHG TO PVNT EXPOS
TO SKIN. WHEN SPRAYING, USE GEN DUST MASK & SFTY GLASSES TO PVNT
INHAL & CNTCT W/EYES. USE ONLY W/ADEQ VENT.
Other Precautions:GENERAL GOOD HOUSEKEEPING MEASURES ARE RECOMMENDED.
PREVENT SPILLS, AVOID CONTACT W/MIST OR SPRAY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED DUST MASK.
Ventilation:LOCAL EXHAUST:FOLLOW OSHA IF DUST/MISTING OCCURS DURING
SPRAYING. MECHANICAL:AS NEEDED.
Other Protective Equipment:OTHER PROTECTIVE CLOTHING, AS SITUATION
WARRENTS. EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
MATLS TO AVOID:TO NEUTRALIZATION OF ALKALINITY.
================== Physical/Chemical Properties ==================
HCC:B3
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:24 @ 77F
Vapor Density:<1
Spec Gravity:1.43
pH:>11
Evaporation Rate & Reference:>1
Solubility in Water:30%
Appearance and Odor:GREY CLAY SLURRY, VISCOUS, MAY HAVE SLIGHT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS, SALTS/ALCOHOLS CAN CAUSE NON-HAZ GELS TO FORM. CNTCT W/ACIDIC
MATLS MAY CAUSES MOD TO LG AMTS OF HEAT DUE(SUPDAT)
==================== Disposal Considerations ====================
Waste Disposal Methods:COMPLY W/FEDERAL, STATE & LOCAL REGULATIONS. IF
AUTHORIZED, REMOVE SOLIDS TO LANDFILL.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:371-44 EVENING SHADE, PACON SUPREME EXTERIOR(SUPDAT)
CAGE:EO376
CAGE:EO376
CAGE:85520
============= Composition/Information on Ingredients =============
Ingred Name:ETHYLENE GLYCOL (SARA 313) (CERCLA). %(WT): 0.00-4.36.
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: <4.36%
OSHA PEL:N/K
ACGIH TLV:50 PPM,VAPOR, C
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:PROPYLENE GLYCOL. %(WT): 0.00-5.00.
CAS:57-55-6
RTECS #:TY2000000
Fraction by Wt: <5.00%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PIGMENT
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:VOLATILE ORGANIC CONTENT: 1.35 - 1.72.
RTECS #:9999999VO
Ingred Name:VENT:IN VOL & PATTERN TO KEEP TLV OF MOST HAZ ING BELOW
ACCEPTABLE LIMS, LEL STATED LIM & TO REMOVE DECOMP PRODS(ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5: DURING WELDING/FLAME CUTTING ON SURFACES COATED
W/THESE PRODUCTS.
RTECS #:9999999ZZ
Ingred Name:RESP PROT: OF PARTICULATE & GAS & VAP IN CONFINED AREAS,
USE (NIOSH/MSHA APPRVD) AIR LINE TYPE RESP/HOODS. (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7: RESP PROT MAY ALSO BE NEC IN ANY LATER MFG OPS IN
WHICH THESE PRODS MAY BECOME AIRBORNE IN FORM/VAP OF DUST.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:REPORTS HAVE ASSOCIATED REPEATED AND
PROLONGED OCCUPATIONAL OVEREXP TO SOLVENTS WITH PERM BRAIN &
NERVOUS SYSTEM DMG. INTENTIONAL MISUSE BY DELIBERATELY CONC &
INHALING CONTENTS MAY BE HARMFUL/FATAL. DO NOT BREATHE VAPORS OR
SPRAY MIST. MAY CONTAIN ONE/MORE REPORTED TERATOGENS/SUSPECTED
TERATOGENS.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH W/LUKE WARM WATER FOR AT LEAST 15 MINS. GET MED
ATTN. SKIN: FLUSH WASH W/COPIOUS AMOUNTS OF LUKEWARM WATER. REMOVE
CONTAMD CLTHG PROMPTLY. INHAL: REMOVE EXPOSED INDIVIDUAL TO FRESH
AIR. ING EST: NEVER GIVE ANYTHING BY MOUTH TO ANUNCON PERS. IF
VICTIM IS CONSCIOUS & ALERT, VOMIT SHOULD BE INDUCED FOR INGESTIONS
FOR MORE THAN ONE SWALLOW)(1-2 TBLSP FOR AN ADULT) PREF W/SYRUP OF
(SUPDAT)
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Extinguishing Media:USE MEDIA SUITABLE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT.
Unusual Fire/Explosion Hazard:CONTAINERS EXPOSED TO INTENSE HEAT FROM
FIRES SHOULD BE COOLED W/WATER TO PREVENT VAPOR PRESSURE BUILDUP
WHICH COULD RESULT IN CONTAINER RUPTURE.
================== Accidental Release Measures ==================
Spill Release Procedures:DO NOT FLUSH TO SEWER, WATERSHED OR WATERWAY.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP FROM FREEZING. DO NOT STORE
>120F. DO NOT TAKE INTERNALLY. CLOSE CONTAINER AFTER EACH USE.
Other Precautions:KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IN OUTDOOR/OPEN AREAS, USE (NIOSH/MSHA
APPRVD)MECH FILTER RESP TO REMOVE SOLID AIRBORNE PARTICLES OF
OVERSPRAY DURING SPRAY APPLIC IN RESTRICTED VENT AREAS,
USE(NIOSH/MSHA APPRVD) CHEMICAL MECH FILTER S DESIGNED TO REMOVE
COMBINATION(ING 7)
Ventilation:USE VENT AS REQD TO CONTROL VAP CONC. AVOID PRLNGD/RPTD
BRTHG OF VAPORS. PROVIDE GENL DILUTION/LOC EXHST VENT (ING 5)
Other Protective Equipment:EMERGENCY EYEWASH & DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA.
Work Hygienic Practices:WASH HANDS THORO BEFORE EATING & USING
WASHROOM. REMOVE CONTAMD CLTHG IMMED & DO NOT WEAR IT UNTIL IT HAS
BEEN(SUPDAT)
Supplemental Safety and Health
TRADENAME/PART NO#: ACRYLIC SEMI-GLOSS HOUSE & TRIM PAINT.
%VOLAT:62.46-66.78. FIRST AID PROC:IPECAC UNDER DIRECTION FROM
MD/POIS CNTRL CENTER. IF SYRUP OF IPEPCAC IS NOT AVAIL, VOMIT CAN
BE INDUCED B Y GENTLY PLACING 2 FINGERS IN BACK OF THROAT. IF POSS,
DO NOT LEAVE VICTIM UNATTENDED. HYGIENE PRAC: PROPERLY LAUNDERED.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>212F,>100C
Vapor Pres:17.0 @ 68F
Vapor Density:HVR/AIR
Spec Gravity:1.09-1.29
Evaporation Rate & Reference:SLOWER THAN BUTYL ACETATE
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:SUPDAT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
THESE PRODUCTS ARE INCOMPATIBLE WITH STRONG ACIDS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:MAY PRDCE HAZ FUMES WHEN HEATED TO
DECOMP. FUMES MAY CNTN CARBON MONOXIDE, CARBON DIOXIDE & OXIDES OF
NITROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:IRON POWDER, 2226
CAGE:70829
CAGE:70829
============= Composition/Information on Ingredients =============
Ingred Name:IRON; (IRON POWDER)
CAS:7439-89-6
RTECS #:NO4565500
Fraction by Wt: 90-100%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL: IRRITATION OF UPPER
RESPIRATORY TRACT. SKIN/EYE CONTACT: IRRITATION. SKIN
ABSORPTION/INGESTION: NONE IDENTIFIED. CHRONIC EFFECTS: NONE
IDENTIFIED.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE IDENTIFIED.
======================= First Aid Measures =======================
First Aid:INGEST: CALL MD. IF CONSCIOUS, GIVE LARGE AMOUNTS OF WATER.
INDUCE VOMITING. INHAL: REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE
ARTIFICIAL RESPIRATION. IF BREATHING IS DIFFICULT, GIVE OXYGEN.
SKIN: FL USH W/WATER. EYES: IMMEDIATELY FLUSH W/PLENTY OF WATER FOR
AT LEAST 15 MINUTES.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Extinguishing Media:USE POWDERED GRAPHITE, POWDERED SALT, OR POWDERED
LIMESTONE. DO NOT USE WATER, CARBON DIOXIDE, OR DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:DUST MAY FORM EXPLOSIVE MIXTURE WITH AIR.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR SUITABLE PROTECTIVE CLOTHING. SHUT OFF
IGNITION SOURCES; NO FLARES, SMOKING, OR FLAMES IN AREA. WITH CLEAN
SHOVEL, CAREFULLY PLACE MATERIAL INTO CLEAN, DRY CONTAINER AND
COVER; REMOVE FROM AREA. FLUSH SPILL AREA W/WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED. STORE
IN COOL, DRY, WELL-VENTILATED AREA AWAY FROM HEAT, SPARKS, OR
FLAME. ISOLATE FROM INCOMPATIBLE MATERIALS.
Other Precautions:CAUSES EYE IRRITATION. MAY BE HARMFUL IF INHALED.
DUST MAY FORM FLAMMABLE OR EXPLOSIVE MIXTURE W/AIR. AVOID CONTACT
W/EYES, SKIN, CLOTHING. DO NOT BREATHE DUST. USE W/ADEQUATE
VENTILATION. WASH THOROU GHLY AFTER HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED WHERE ADEQUATE VENTILATION
CONDITIONS EXIST. IF AIRBORNE CONCENTRATION IS HIGH, USE AN
APPROPRIATE NIOSH/MSHA APPROVED RESPIRATOR OR DUST MASK.
Ventilation:USE ADEQUATE GENERAL OR LOCAL EXHAUST VENTILATION TO KEEP
FUME OR DUST LEVELS AS LOW AS POSSIBLE.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:4982F,2750C
Melt/Freeze Pt:M.P/F.P Text:2795F,1535C
Spec Gravity:7.87 (H*2O=1)
Solubility in Water:NEGLIGIBLE (<0.1%)
Appearance and Odor:SILVER-WHITE TO GRAY POWDER.
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, STRONG OXIDIZING AGENTS, WATER, MINERAL ACIDS.
Stability Condition to Avoid:AIR, MOISTURE, DUSTING.
Hazardous Decomposition Products:NONE IDENTIFIED.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE W/ALL APPLICABLE FEDERAL,
STATE, AND LOCAL ENVIRONMENTAL REGULATIONS. EPA HAZARDOUS WASTE
NUMBER: D001 (IGNITABLE WASTE).
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:8915-856 MT-STARTER III EP550Z
CAGE:23736
CAGE:23736
============= Composition/Information on Ingredients =============
Ingred Name:STYRENE BUTYLACRYLATE COPOLYMER
Fraction by Wt: <90%
Ingred Name:IRON OXIDE, MAGNETITE
CAS:1317-61-9
Fraction by Wt: <90%
Ingred Name:PROPENE POLYMERS, POLYPROPYLENE
CAS:9003-07-4
RTECS #:UD1842000
Fraction by Wt: <10%
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: <10%
Other REC Limits:3.5 MG/CUM (NIOSH)
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3; 9192
Ingred Name:PIGMENT
Fraction by Wt: <10%
Other REC Limits:10 MG/CUM (DUST)
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT): >5 G/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: RESPIRATORY TRACT
IRRITATION, COUGH, & PHLEGM.
Explanation of Carcinogenicity:CARBON BLACK IS SUSPECTED TO BE A HUMAN
CARCINOGEN BY ACGIH.
Effects of Overexposure:INHALATION: RESPIRATORY TRACT IRRITATION,
COUGH, & PHLEGM.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. SKIN: WASH W/SOAP & WATER.
OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER, FOAM, DRY CHEMICAL.
Unusual Fire/Explosion Hazard:TONER IS A COMBUSTIBLE POWDER. WHEN
DISPERSED IN AIR, IT FORMS EXPLOSIVE MIXTURES.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP OR VACUUM.
======================Handling and Storage ======================
Other Precautions:DON'T BURN. AVOID BREATHING OF SMOKE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED WHEN USED AS INTENDED.
MAY BE REQUIRED.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Spec Gravity:2.3
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLACK POWDER W/FAINT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:NO SPECIAL REQUIREMENT. DISPOSE OF IN ACCORDANCE
W/LOCAL, STATE, & FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:DIESEL
CAGE:1DL10
CAGE:1DL10
============= Composition/Information on Ingredients =============
Ingred Name:SATURATED HYDROCARBONS
Fraction by Wt: 54-85%
Other REC Limits:NONE RECOMMENDED
Ingred Name:UNSATURATED HYDROCARBONS
Fraction by Wt: 1-6%
Other REC Limits:NONE RECOMMENDED
Ingred Name:AROMATIC HYDROCARBONS
Fraction by Wt: 15-45%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE-SHORT TERM LIQUID OR VAPOR CONTACT
MAY RESULT IN SLIGHT EYE IRRITATION. SKIN-CAN CAUSE DEFATTING &
DRYING OF THE SKIN WHICH MAY PRODUCE SEVER IRRITATION OR
DERMATITIS. INGESTION-HIGH VAPOR CONCENT RATION MAY PRODUCE
HEADACHE, GIDDINESS,VERTIGO, & STUPOR. INGEST-RESULT IN NAUSEA,
VOMITING, DIARRHEA & RESTLESSNESS.
Explanation of Carcinogenicity:NONE SPECIFIED BY MANUFACTURER.
Effects of Overexposure:HIGH VAPOR CONCENTRATIONS (GREATER THAN 1000
PPM, ATTAINABLE AT TEMPERATURES WELL ABOVE AMBIENT) ARE IRRITATING
TO THE EYES AND THE RESPIRATORY TRACT, AND MAY CAUSE HEADACHE,
DIZZINESS, ANESTHESIA, DR OWSINESS, UNCONSCIOUSNESS AND OTHER
CENTRAL NERVOUS SYSTEM EFFECTS, INCLUDING DEATH.
Medical Cond Aggravated by Exposure:SKIN CONTACT MAY AGGRAVATE AN
EXISTING DERMATITIS.
======================= First Aid Measures =======================
First Aid:EYES-FLUSH EYES WITH LARGE AMOUNTS OF WATER FOR AT LEAST 15
MIN. CONTACT A PHYSICIAN. SKIN-WASH WITH SOAP & LARGE AMOUNTS OF
WATER. REMOVE CONTAMINATED CLOTHING. CONTACT A PHYSICIAN.
INHALATION-MOVE P ERSON TO FRESH AIR. IF NOT BREATHING ORIF NO
HEARTBEAT, GIVE ARTIFICIAL RESPIRATION OR CPR. CONTACT A PHYSICIAN.
INGESTION-DO NOT INDUCE VOMITING. DO NOT GIVE LIQUIDS. CALL A
PHYSICIAN IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point:130F,54C
Autoignition Temp:Autoignition Temp Text:494F
Lower Limits:0.7
Upper Limits:5.0
Extinguishing Media:CLASS B FIRE EXTINGUISHING MEDIA SUCH AS HALON,
CARBON DIOXIDE, DRY CHEMICAL CAN BE USED.
Fire Fighting Procedures:WATER MAY BE INEFFECTIVE BUT MAY BE USED TO
COOL FIRE EXPOSED CONTR. USE SUPPLIED AIR BREATHING EQUIPMENT FOR
ENCLOSED OR CONFINED SPACES OR AS OTHERWISE NEEDED
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:KEEP PUBLIC AWAY. SHUT OFF SOURCE OF LEAK IF
POSSIBLE, WITHOUT RISK HAZARD. ELIMINATE IGNITION SOURCES. IF
APPROPIATE, CONTAIN LIQUID WITH SAND OR SOIL, RECOVER AND RETURN
FREE LIQUID TO SOURCE. USE S UITABLE SORBENT TO CLEANUP RESIDUAL
LIQUID.
======================Handling and Storage ======================
Handling and Storage Precautions:PRODUCT SHOULD BE HANDLED & STORED IN
ACCORDANCE WITH INDUSTRY ACCEPTABLE PRACTICES. STORE IN PROPERLY
CLOSED CONTAINERS THAT AREA APPROPIATELY LABELD
Other Precautions:DO NOT EXPOSE TO HEAT, OPEN FLAME, OXIDIZERS OR OTHER
SOURCES OF IGNITION. AVOID SKIN CONATCT. EXERCISE GOOD PERSONAL
HYGIENE INCLUDING REMOVAL OF SOILED CLOTHING AND PROMPT WASHING
WITH SOAP AND WATE R.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:APPROVED ORGANIC VAPOR CARTRIDGE OR SUPPLIED AIR
RESPIRATORS SHOULD BE WORN FOR EXPOSURE EXCEEDING THE TLV OR STEL.
SELF-CONTAINED BREATHING APPARATUS SHOULD BE USED FOR FIRE
FIGHTING.
Ventilation:USE MECHANICAL VENTILATION EQUIPMENT THAT IS EXPLOSION
PROOF.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
LIQUID IS TOXIC TO AQUATIC LIFE.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:320-66F
Vapor Pres:1-10 MMHG
Vapor Density:4-5
Spec Gravity:0.8
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR AMBER LIQUID, CLEAR GOLDEN BROWN LIQUID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS.
Stability Condition to Avoid:THIS MATERIAL IS TABLE AT 70F, 760 MM
PRESSURE.
Hazardous Decomposition Products:CARBON MONOXIDE, ALDEHYDES, AROMATIC
HYDROCARBONS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF CLEANUP MATERIALS IN ACCORDANCE WITH
APPLICABLE LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CAT, MIL-C-83286 36622 P/C 03GY062CAT
Kit Part:Y
Preparer's Name:NORM GAUL
CAGE:5M511
CAGE:33461
CAGE:5M511
============= Composition/Information on Ingredients =============
Ingred Name:ALIPHATIC ISOCYANATE BIURET OF HMDI
CAS:4035-89-6
Fraction by Wt: 30%
Other REC Limits:NONE RECOMMENDED
ACGIH TLV:0.005 PPM TWA
Ingred Name:HEXAMETHYLENE DIISOCYANATE [HDI] FREE MONOMER >0.5% AT
TIME OF MFR, AFTER 3-6 MO, MAY RISE TO MAX 1.6%.
CAS:822-06-0
RTECS #:MO1740000
Fraction by Wt: 0.5-1.6%
Other REC Limits:NONE RECOMMENDED
ACGIH TLV:0.005 PPM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:N-BUTYL ACETATE (SARA III) (VAPOR PRESSURE 13 MM HG @ 68F)
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: <5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:150 PPM;STEL 200 PPM
ACGIH TLV:150 PPM;STEL 200 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:XYLENE (SARA III) (VAPOR PRESSURE 21 MM HG @ 100F)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 4.09%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM;STEL 150 PPM
ACGIH TLV:100 PPM;STEL 150 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ETHYL BENZENE (SARA III) (VAPOR PRESSURE 7.1 MM HG @ 68F)
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: 0.84%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM;STEL 125 PPM
ACGIH TLV:100 PPM;STEL 125 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:TOLUENE (SARA III) (VAPOR PRESSURE 22 MM HG @ 68F)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 2.98%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM;STEL 150 PPM
ACGIH TLV:100 PPM;STEL 150 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ETHYL 3-ETHOXYPROPIONATE (VAPOR PRESSURE 0.7 MM HG @ 68F)
CAS:763-69-9
RTECS #:UF3325000
Fraction by Wt: 5%
Other REC Limits:50 PPM; STEL 100 PPM
Ingred Name:METHYL ISOBUTYL KETONE (SARA III) (VAPOR PRESSURE 15 MM HG
@ 68F)
CAS:108-10-1
RTECS #:SA9275000
Fraction by Wt: 8.94%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:50 PPM; STEL 75 PPM
ACGIH TLV:50 PPM; STEL 75 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:METHYL ETHYL KETONE (SARA III) (VAPOR PRESSURE 70 MM HG @
68F)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 43.4%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:200 PPM;STEL 300 PPM
ACGIH TLV:200 PPM;STEL 300 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:VOC: 633 G/L
RTECS #:9999999VO
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL: RESP TRACT IRRIT,NERV SYS
DEPRESS (HEADACHE,DIZZY,STAGGER,CONFUSION,UNCONSCIOUS,COMA). SKIN:
ISOCYANATE REACT W/PROTEIN CAUSING IRRIT (SWELL,RED,RASH). ABSORPT:
IRRIT,DRYING,DEFATTING (CRACKING ). EYE: IRRIT (TEAR,RED,SWELL
W/STING).INGEST: IRRIT,CORROSIVE IN GI TRACT. VOMIT MAY CAUSE
ASPIRATION-CHEM PNEUMONITIS
Effects of Overexposure:ACUTE: VAPOR IRRITATING TO EYES, NOSE, THROAT.
INHALATION MAY CAUSE HEADACHES, DIFFICULT BREATHING &
UNCONSCIOUSNESS. CHRONIC: AS RESULT OF PREVIOUS REPEATED
OVEREXPOSURE OR SINGLE LARGE DOSE , SOME WILL DEVELOP ISOCYANATE
SENSITIZATION WHICH WILL CAUSE THEM TO REACT TO LATER ISOCYANATE
EXPOSURE WELL BELOW TLV.
Medical Cond Aggravated by Exposure:ASTHMA AND ANY OTHER RESPIRATORY
DISORDERS. SKIN ALLERGIES, ECZEMA, AND DERMATITIS. ISOCYANATE
SENSITIZATION.
======================= First Aid Measures =======================
First Aid:INHAL: MOVE TO FRESH AIR. RESTORE BREATHING. ASTHMATIC TYPE
SYMPTOMS MAY DEVELOP. GET MEDICAL AID. SKIN: REMOVE CONTAMINATED
CLOTHES. WASH AFFECTED AREAS W/SOAP & WATER. WASH CONTAMINATED
CLOTHING BEF ORE REUSE. EYES: FLUSH W/LUKEWARM WATER(LOW PRESSURE)
15 MIN, OCCASIONALLY LIFTING EYELIDS. GET MED AID. INGESTION: DO
NOT INDUCE VOMITING. DO NOT GIVE ANYTHING TO AN UNCONSCIOUS PERSON.
GET MED AID.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:23.0F,-5.0C
Lower Limits:1.00
Upper Limits:11.00
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG,
WATER SPRAY
Fire Fighting Procedures:USE FULL PROTECT CLOTH/FIREFIGHT EQUIP W/SCBA.
WATER MAY BE USED TO COOL CLSD CNTNRS (PREVENT PRESS
BLDUP/AUTOIGNIT/EXPLOS). HDI/IRRIT VAPOR GENERATED BY FIRE.
Unusual Fire/Explosion Hazard:KEEP CNTNR CLSD. KEEP FROM HEAT/IGNIT
SOURCE. CLSD CNTNR MAY EXPLODE W/HEAT. APPLIC TO HOT SURFACE REQ
SPECIAL PRECAUTION. OVEREXPOSURE TO DECOMP PROD-HLTH HZD.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE ALL NON-ESSENTIAL PERSONNEL. REMOVE
ALL SOURCES OF IGNITION (FLAME, SPARK SOURCES, HOT SURFACES).
VENTILATE AREA. CONTAIN AND REMOVE WITH INERT ABSORBENT AND
NON-SPARKING TOOLS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN BLDGS IN COMPLY W/OSHA
1910.106. AVOID STORING NEAR HIGH TEMPERATURES/IGNITION SOURCES.
STORE IN CLOSED CONTAINERS IN WELL VENTILATED AREA.
Other Precautions:KEEP CONTAINERS TIGHT & UPRIGHT (PREVENT LEAK).
PREVENT PROLONGED VAPOR BREATHING. PROLONGED OVEREXPOSURE MAY CAUSE
ALLERGIC REACTION. AVOID CONTACT WITH SKIN & EYES. DO NOT INGEST.
DON'T HANDLE TILL MFR SFTY PRECAUTIONS READ/UNDERSTOOD.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:A RESPIRATOR RECOMMENDED FOR ORGANIC VAPOR
ENVIRONMENT (AIR PURIFYING OR FRESH AIR SUPPLIED). OBEY OSHA REGS
FOR RESPIRATOR USE. PROVIDE VENT TO KEEP EXPOSURE LEVELS BELOW PEL.
USE VAPOR PARTICULATE R SPRTR (TC23C) WHEN BELOW 10X TLV/PEL.
Ventilation:EXHAUST VENT TO KEEP AIRBORNE CONCENTRATIONS BELOW TLV'S.
REMOVE ALL IGNITION SOURCES.
Other Protective Equipment:THE USE OF LONG SLEEVE AND LONG LEG CLOTHING
IS RECOMMENDED. REMOVE AND WASH CONTAMINATED CLOTHING BEFORE REUSE.
Work Hygienic Practices:WASH HANDS BEFORE EATING, SMOKING, OR USING
WASHROOM. SMOKE IN SMOKING AREAS ONLY.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:175 TO 338F
Vapor Density:>AIR
Spec Gravity:0.90036
Viscosity:*
Evaporation Rate & Reference:3.24 X N-BUTYL ACETATE
Solubility in Water:INSOLUBLE
Appearance and Odor:AMBER LIQUID WITH SOLVENT ODOR
Percent Volatiles by Volume:76.9
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER, AMINES, STRONG BASES, ALCOHOLS, METAL COMPOUNDS AND SURFACE
ACTIVE MATERIALS.
Stability Condition to Avoid:CONTACT WITH MOISTURE, MATERIAL WHICH
REACT WITH ISOCYANATES AND HIGH TEMPERATURES.
Hazardous Decomposition Products:BY HIGH HEAT/TEMPERATURE: CARBON
MONOXIDE, CARBON DIOXIDE, AND OXIDES OF NITROGEN, TRACES OF HCN &
HDI.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF WASTE IN ACCORDANCE WITH FEDERAL,
STATE, & LOCAL ENVIRONMENTAL CONTROL REGULATIONS. EMPTY CONTAINERS
MUST BE HANDLED WITH CARE, DUE TO PRODUCT RESIDUE & FLAMMABLE
VAPOR. DON'T INCINERATE CL OSED CONTAINERS. EPA CODE: D001, F003,
F005.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CARRIAGE HOUSE ACRYLIC HOUSE PAINT MIDTONE BASE, 693
CAGE:EO376
CAGE:EO376
CAGE:85520
============= Composition/Information on Ingredients =============
Ingred Name:SILICA, CRYSTALLINE - QUARTZ; (CRYSTALLINE SILICA)
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 23.34%
OSHA PEL:SEE TABLE Z-3
ACGIH TLV:0.1 MG/M3 RDUST;9495
Ingred Name:ETHYLENE GLYCOL (SARA 313) (CERCLA)
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: 1.80%
OSHA PEL:N/K
ACGIH TLV:C 50 PPM,VAPOR; 9495
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:VOLATILE ORGANIC CONTENT: 0.899
RTECS #:9999999VO
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPDAT:TO KEEP TLV OF THE MOST HAZ ING IN ING SECTION BELOW
ACCEPTABLE LIMIT, LEL BELOW STATED(ING 4)
RTECS #:9999999ZZ
Ingred Name:ING 3:LIMIT, & TO REMOVE DECOMP PRODUCTS DURING WELDING
/FLAME CUTTING ON SURFACES COATED W/THIS PRODUCT.
RTECS #:9999999ZZ
Ingred Name:RESP PROT:A COMBINATION OF PARTICULATE & GAS & VAP. IN
CONFINED AREAS USE (NIOSH/MSHA APPRVE) AIR LINE TYPE RESPS(ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6:OR HOODS. RESP PROT MAY ALSO BE NEC IN ANY LATER MFRG
OPS IN WHICH PROD MAY BECOME AIRBORNE IN FORM OF VAP/DUST.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:REPORTS HAVE ASSOCIATED REPEATED AND
PROLONGED OCCUPATIONAL OVEREXPOSURE TO SOLVENTS WITH PERMANENT
BRAIN AND NERVOUS SYSTEM DAMAGE. INTENTIONAL MISUSE BY DELIBERATELY
CONCENTRATING AND INHALING THE C ONTENTS MAY BE HARMFUL OR FATAL.
THIS PRODUCT CONTAINS CRYSTALLINE SILICA (CS), WHICH IS CONSIDERED
A (EFTS OF OVEREXP)
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-QUARTZ:IARC
MONOGRAPHS, SUPPLEMENT. VOL 7, PG 341, 1987: GROUP 2A. NTP 7TH
ANNUAL REPORT ON(SUPDAT)
Effects of Overexposure:HLTH HAZ:HAZARD BY INHALATION. CS IN ITS
PHYSICAL STATE AS A DRY, WHITE POWDER IS NOT ENCOUNTERED WHEN
HANDLING/USING A PACKAGED PAINT PRODUCT CONTAINING PRE-WETTED
PIGMENT. CS IS ALSO KNOWN CAUSE OFSILICOSIS. BASED ON THE
PRESENCE OF COMPONENT (2) THIS PRODUCT CAN BE IRRIT TO THE EYES.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH W/LUKE WARM H*2O FOR AT LEAST 15 MIN. SEEK MD
IMMED. SKIN:FLUSH WASH W/COPIOUS AMTS OF LUKE WARM H*2O. REMOVE
CONTAMD CLTHG PROMPTLY. CNTCT MD IMMED. INHAL:REMOVE EXPOSED
INDIVIDIAL TO FRESH AIR. RESTORE BRTHG IF REQD. CNTCT MD IMMED.
INGEST:RINSE MOUTH IMMED. GIVE EXPOSED INDIVIDUAL 6 TO 8 OUNCES OF
LIQ. (NEVER GIVE ANYTHING BY MOUTH TO UNCON PERS) DO NOT INDUCE
VOMIT UNLESS (SUPDAT)
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Extinguishing Media:USE CO*2, DRY CHEMICAL OR FOAM EXTINGUISHER.
Fire Fighting Procedures:USE NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIPT
. H*2O SPRAY MAY BE INEFT. H*2O MAY BE USED TO COOL CLSD CNTNRS TO
PVNT PRESS BUILDUP & POSS (SUPDAT)
Unusual Fire/Explosion Hazard:CONTAINERS EXPOSED TO INTENSE HEAT FROM
FIRE SHOULD BE COOLED W/H*2O TO PREVENT VAPOR PRESSURE BUILDUP
WHICH COULD RESULT IN CONTAINER RUPTURE.
================== Accidental Release Measures ==================
Spill Release Procedures:NONE SPECIFIED BY MANUFACTURER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP FROM FREEZING. DO NOT STORE ABOVE
120F. DO NOT TAKE INTERNALLY. CLOSE CNTNR AFTER EACH USE. KEEP OUT
OF REACH OF CHILDREN.
Other Precautions:DO NOT BREATHE VAPOR OR SPRAY MIST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IN OUTDOOR/OPEN AREAS USE (NIOSH/MSHA APPROVED)
MECH FILTER RESP TO REMOVE SOLID AIRBORNE PARTICLES OF OVERSPRAY
DURING SPRAY APPLICATN. IN RESTRICTED VENT AREAS USE (NIOSH/MSHA
APPRVD) CHEM-MECHANICA L FILTERS DESIGNED TO REMOVE (ING 6)
Ventilation:USE VENT AS REQD TO CTL VAP CONCS. AVOID PRLNG/RPTD BRTHG
OF VAP. IF EXPOS EXCEEDS TLV, USE NIOSH/MSHA APPRVD (SUPDAT)
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:WASH HANDS THOROUGHLY BEFORE EATING AND USING
WASHROOM. REMOVE CONTAM CLTHG IMMED & DO NOT WEAR UNTIL PROPERLY
LAUNDRED.
Supplemental Safety and Health
FIRE FIGHT PROC:AUTOIGNITION/EXPLOSION WHEN EXPOSED TO EXTREME HEAT. IF
H*2O IS USED, FOG NOZZLES ARE PREF. EXPLAN OF CARCIN:CARCINOGENS,
1994:ANTICIPATED TO BE CARCINOGEN. FIRST AID PROC:ADVISED BY M D.
CNTCT MD IMMED. VENT:RESP TO PVNT OVEREXPOS. PROVIDE GENERAL
DILUTION/LOCAL EXHST VENT IN VOL & PATTERN (ING 4)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>212F,>100C
Vapor Pres:17 @ 68F
Vapor Density:HVR/AIR
Spec Gravity:1.33
Evaporation Rate & Reference:SLOWER THAN BUTYL ACETATE
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:63.03
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
THIS PRODUCT IS INCOMPATIBLE WITH STRONG ACIDS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:MAY PRODUCE HAZ FUMES WHEN HEATED TO
DECOMP AS IN WELDING. FUMES MAY CONTAIN CO, CARBON DIOXIDE, &
OXIDES OF NITROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT FLUSH TO SEWER, WATERSHED, OR WATERWAY.
DISPOSE OF PRODUCT IN ACCORDANCE WITH APPLICABLE LOCAL, COUNTY,
STATE, AND FEDERAL REGULATION.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:FLORCO-X
CAGE:FLORI
CAGE:FLORI
============= Composition/Information on Ingredients =============
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 0-3%
Other REC Limits:0.05 MG/CUM NIOSH
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
Ingred Name:MAGNESIUM ALUMINUM SILICATE
CAS:8031-18-3
Fraction by Wt: 100%
ACGIH TLV:10 MG/CUM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: HARMFUL, DELAYED INJURY TO
LUNGS (SILICOSIS), UNDUE BREATHLESSNESS, COUGHING, & SPUTUM
PRODUCTION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: HARMFUL, DELAYED INJURY TO LUNGS
(SILICOSIS), UNDUE BREATHLESSNESS, COUGH, & SPUTUM PRODUCTION.
======================= First Aid Measures =======================
First Aid:NONE
===================== Fire Fighting Measures =====================
Extinguishing Media:NOT FLAMMABLE
Fire Fighting Procedures:NO FIRE OR EXPLOSION HAZARD
================== Accidental Release Measures ==================
Spill Release Procedures:NO SPECIAL PRECAUTIONS REQUIRED.
======================Handling and Storage ======================
Handling and Storage Precautions:USE APPROPRIATE SYSTEMS FOR HANDLING,
STORAGE, & CLEAN UP SO THAT AIR BORNE DUST DOESN'T EXCEED PEL. USE
ADEQUATE VENTILATION & DUST COLLECTION.
Other Precautions:PRACTICE GOOD HOUSEKEEPING. HEAT GENERATION MAY OCCUR
WHEN THE FULLER'S EARTH IS MIXED W/A POLYUNSATURATED LIQUID. HEAT
RISES TO 350F, WHEN FLORCO W/0.0% FREE MOISTURE IS MIXED
W/TURPENTINE. NO REACTI ON IF FLORCO CONTAINS 5% FREE MOISTURE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED DUST MASK RESPIRATOR UNDER
APPROPRIATE OSHA STANDARDS & REGULATIONS.
Ventilation:USE SUFFICIENT LOCAL EXHAUST VENTILATION TO REDUCE DUST TO
KEEP BELOW PEL FOR RESPIRABLE QUARTZ.
Work Hygienic Practices:PRACTICE GOOD HOUSEKEEPING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>1000C
Spec Gravity:1.47
Solubility in Water:INSOLUBLE
Appearance and Odor:GRAY, TAN, REDDISH TAN GRANULAR OR POWDER W/EARTHY
ODOR WHEN WET.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
TURPENTINE
Stability Condition to Avoid:HEAT GENERATION MAY OCCUR WHEN THE
FULLER'S EARTH IS MIXED WITH A POLYUNSATURATED LIQUID OR
TURPENTINE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/FEDERAL, STATE, &
LOCAL REGULATIONS FOR THE MATERIAL & FOR THE LIQUID ABSORBED. WHEN
POLYUNSATURATED LIQUID IS ABSORBED, PLACE IN COVERED METAL
CONTAINER TO AVOID SPONTANEOU S COMBUSTION.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:570A, COOL'R CLEAN'R HEAVY DUTY COMPLETE'R A
Preparer's Name:DAWN WILSON
CAGE:58579
CAGE:58579
CAGE:0WA27
CAGE:1B8P5
CAGE:1U435
============= Composition/Information on Ingredients =============
Ingred Name:PHOSPHORIC ACID (SARA 313) (CERCLA)
CAS:7664-38-2
RTECS #:TB6300000
Fraction by Wt: 12-20%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3/3 STEL; 9495
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:COMPLETE MIXTURE
Fraction by Wt: 80-90%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:PRODUCT'S LD50 (ORAL RAT) WAS NOT STATED
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PROLONGED &/OR REPEATED SKIN CONTACT
MAY CAUSE IRRITATION. DIRECT EYE CONTACT WITH PRODUCT MAY CAUSE
IRRITATION. INHALATION OF MIST MAY IRRITATE RESPIRATORY PASSAGES.
MAY BE HARMFUL IF SWALLOWED.
Explanation of Carcinogenicity:MFR GAVE THE ABOVE LISTINGS ON THE MSDS
BUT NO OTHER COMMENTS ABOUT CARCINOGENICITY WERE RECORDED.
Effects of Overexposure:PROLONGED &/OR REPEATED SKIN
CONTACT:IRRITATION. EYE CONTACT:IRRITATION. INHALATION:(OF
MIST)RESPIRATORY IRRITATION. INGESTION:MAY BE HARMFUL.
Medical Cond Aggravated by Exposure:MFR GAVE NO INFORMATION ON MSDS.
======================= First Aid Measures =======================
First Aid:IF IRRITATION PERSISTS OR IS SEVERE, GET MEDICAL ATTENTION.
EYE:FLUSH W/WATER FOR 15 MIN. SKIN:WASH W/SOAP & WATER. REMOVE
CONTAMINATED CLOTHING & LAUNDER BEFORE REUSE. INHALED:REMOVE FROM
EXPOSURE. A ID OR RESTORE BREATHING AS NEEDED. INGESTED:DO NOT
INDUCE VOMITING, GET IMMEDIATE MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:FIREFIGHTERS SHOULD WEAR PROTECTIVE GEAR
INCLUDING SELF-CONTAINED BREATHING APPARATUS. USE MEDIA APPROPRIATE
FOR SURROUNDING FIRE.
Unusual Fire/Explosion Hazard:MFR GAVE NO INFORMATION ON MSDS.
================== Accidental Release Measures ==================
Spill Release Procedures:NOTIFY EMERGENCY RESPONSE PERSONNEL. EVACUATE
AREA. REMOVE IGNITION SOURCES. BUILD DIKE TO CONTAIN SPILL. REMOVE
FREE LIQUID. DO NOT FLUSH INTO SEWER OR OPEN WATER STREAM. PICKUP
W/INERT ABSORBENT & P LACE IN CLOSED CONTINER FOR DISPOSAL.
Neutralizing Agent:MFR GAVE NO INFORMATION ON MSDS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE CONTAINERS CLOSED AWAY FROM
EXTREME TEMPERATURES.
Other Precautions:USE GOOD CHEMICAL HYGIENE PRACTICES. DO NOT SMOKE
WHILE USING PRODUCT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AS REQUIRED BY EXPOSURE.
Ventilation:USE ADEQUATE MECHANICAL VENTILATION.
Other Protective Equipment:WEAR LONG SLEEVED SHIRT WHEN USING PRODUCT.
LAUNDER CLOTHING BEFORE REUSE.
Work Hygienic Practices:USE GOOD CHEMICAL HYGIENE PRACTICES.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:C1
NRC/State Lic Num:NONE
Boiling Pt:B.P. Text:>212F,>100C
Spec Gravity:1.08
Solubility in Water:APPRECIABLE
Appearance and Odor:BLUE LIQUID. CAUSTIC ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:MFR GAVE NO INFORMATION ON MSDS.
Hazardous Decomposition Products:THERMAL DECOMPOSITION PRODUCTS MAY
INCLUDE OXIDES OF CARBON & NITROGEN.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:UTILIZE LICENSED WASTE DISPOSAL COMPANY. OBSERVE
LOCAL, STATE & FEDERAL REGULATIONS. ALL COMPONENTS ARE LISTED ON
TSCA INVENTORY.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:EMBECO 885 GROUT, 05130
CAGE:FO873
CAGE:98898
CAGE:FO873
============= Composition/Information on Ingredients =============
Ingred Name:SILICATE, PORTLAND CEMENT; (PORTLAND CEMENT)
CAS:65997-15-1
RTECS #:VV8770000
Fraction by Wt: 30-60%
OSHA PEL:50 MPPCF
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 10-30%
OSHA PEL:10 MG/M3 (MFR)
ACGIH TLV:0.1 MG/M3 RDUST
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHALATION:NUISANCE DUST MAY
CAUSE TEMPORARY BUT REVERSIBLE RESPIRATORY PROBLEMS. EYES:ABRASIVE
ACTION MAY CAUSE DAMAGE TO OUTER SURFACE. MAY CAUSE SEVERE
IRRITATION WITH CORNEAL INJURY. SKIN CO NTACT:IN COMBINATION WITH
WATER DERMAL EXPOSURE MAY CAUSE SEVERE ALKALI BURNS. SKIN
ABSORPTION/INGEST: (EFTS OF OVEREXP)
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-QUARTZ:IARC
MONOGRAPHS, SUPP, VOL 7, PG 341, 1987:GRP 2A. NTP 7TH ANNUAL
REPORTS ON CARCINS,(SUPDAT)
Effects of Overexposure:HLTH HAZ:NOT APPLIC. CHRONIC:RPTD INHAL OF RESP
SILICA IN EXCESS OF TLV OVER EXTENDED PERIODS CAN RSLT IN
IRREVERSIBLE FIBROSIS OF LUNGS (SILICOSIS). THERE IS LTD EVID OF
CARCIN OF CRYSTALLINE SILICA TO HUMANS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD IMMEDIATELY . INHAL:REMOVE TO FRESH AIR.
EYES:FLUSH W/COPIOUS AMOUNTS OF WATER FOR AT LEAST 15 MINUTES.
CONTACT MD. SKIN:WASH W/SOAP & WATER.
===================== Fire Fighting Measures =====================
Extinguishing Media:THIS MATL DOES NOT GIVE FLASH POINT BY CONVENTIONAL
TEST METHS. USE EXTING AGENT SUITABLE FOR TYPE OF SURROUNDING FIRE.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
================== Accidental Release Measures ==================
Spill Release Procedures:NO SPECIAL PROCEDURES ARE REQUIRED FOR
CLEAN-UP OF SPILLS OR LEAKS OF THIS MATERIAL. SWEEP UP & RETURN FOR
REUSE OR DISCARD.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM WET, DAMP CONDITIONS.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED DUST MASKS.
Ventilation:VENTILATION MAY BE USED TO CONTROL OR REDUCE AIRBORNE
CONCENTRATIONS.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . NORMAL CLOTHING.
Work Hygienic Practices:DO NOT WEAR CONTACT LENSES WHEN WORKING W/THIS
PRODUCT.
Supplemental Safety and Health
EXPLAN OF CARCIN:1994:ANTICIPATED TO BE CARCINOGEN .
================== Physical/Chemical Properties ==================
Solubility in Water:SLIGHT
Appearance and Odor:DARK GRAY POWDER; ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:THIS PRODUCT, WHEN DISCARDED OR DISPOSED OF, IS
NOT LISTED AS A HAZARDOUS WASTE IN FEDERAL REGULATIONS. DISPOSE OF
I/A/W LOCAL, STATE & FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:42CA680224 POLAR WHITE
CAGE:0G0J3
CAGE:0G0J3
============= Composition/Information on Ingredients =============
Ingred Name:SEC-BUTANOL ALCOHOL *97-4*
CAS:78-92-2
RTECS #:EO1750000
Fraction by Wt: >5%
Other REC Limits:100 PPM
OSHA PEL:150 PPM
ACGIH TLV:303 MG/CUM
Ingred Name:V M & P NAPHTHA, LIGROINE, MINERAL SPIRITS *97-4*
CAS:8032-32-4
RTECS #:OI6180000
Fraction by Wt: >5%
Other REC Limits:STEL 400 PPM
ACGIH TLV:300 PPM
Ingred Name:ACETONE; DIMETHYL KETONE; 2-PROPANONE *97-4*
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 30%
OSHA PEL:2400 MG/CUM
ACGIH TLV:750 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:PROPANE (DIMETHYLMETHANE)*97-4*
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 10%
Other REC Limits:1800 MG/CUM
OSHA PEL:1000 PPM
ACGIH TLV:SIMPLE ASPHYXIANT
Ingred Name:ISOBUTANE, 2-METHYLPROPANE
CAS:75-28-5
RTECS #:TZ4300000
Fraction by Wt: 10%
Other REC Limits:1000 PPM
OSHA PEL:1800 MG/CUM
ACGIH TLV:1000 PPM
Ingred Name:TOLUENE (IARC CARC- GROUP 3) *97-4*
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: >5%
Other REC Limits:375 MG/CUM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:2-BUTOXYETHANOL (ETHYLENE GLYCOL MONOBUTYL ETHER), BUTYL
CELLOSOLVE, BUTYL GLYCOL, GLYCOL ETHER EB *97-4*
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: >5%
Other REC Limits:25 PPM (SKIN)
OSHA PEL:50 PPM (SKIN)
ACGIH TLV:25 PPM (SKIN)
Ingred Name:PROPYLENE GLYCOL METHYL ETHER (1-METHOXY-2-PROPANOL)
PROPYLENE GLYCOL MONO METHYL ETHER *97-4*
CAS:107-98-2
RTECS #:UB7700000
Fraction by Wt: >5%
Other REC Limits:100 PPM
ACGIH TLV:100 PPM
Ingred Name:BENZIN, NAPHTHA, MINERAL SPIRITS, PETROLEUM NAPHTHA
CAS:8030-30-6
RTECS #:DE3030000
Fraction by Wt: 10%
Other REC Limits:STEL 400 PPM
OSHA PEL:100 PPM
ACGIH TLV:300 PPM
Ingred Name:XYLENE, DIMETHYLBENZENE, XYLOL (IARC - GROUP 3) *97-4*
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: >5%
Other REC Limits:100 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM, SKIN
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INGESTION: HARMFUL/FATAL. EYES/SKIN:
IRRITATION. INHALATION: ANESTHETIC, WILL IRRITATE THE RESPIRATORY
TRACT & MAY CAUSE NERVOUS SYSTEM DEPRESSION. REPEATED/PROLONGED
OVEREXPOSURE TO SOLVENTS MAY CAUS E PERMANENT BRAIN & NERVOUS
SYSTEM DAMAGE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, DROWSINESS, LIGHTHEADEDNESS,
HEADACHE, DIZZINESS, STAGGERING, CONFUSION, UNCONSCIOUSNESS, COMA.
======================= First Aid Measures =======================
First Aid:INGESTION: DON'T INDUCE VOMITING. EYES: FLUSH W/LAARGE
AMOUNTS OF WATER FOR 15 MINS. SKIN: WASH W/SOAP & WATER.
INHALATION: REMOVE TO FRESH AIR. GIVE CPR/OXYGEN IF NECESSARY.
OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:<0F
Lower Limits:2.3
Extinguishing Media:CO2, DRY CHEMICAL/FOAM.
Fire Fighting Procedures:WATER SPRAY MAY BE INEFFECTIVE BUT MAY BE USED
TO COOL CLOSED CONTAINERS. IF WATER IS USED, FOG NOZZLES ARE
PREFERABLE. WEAR SCBA.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. DON'T APPLY ON HOT SURFACES. AEROSOL
CONTAINERS HOLD EXTREMELY FLAMMABLE GAS & LIQUID UNDER PRESSURE
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE SOURCES OF IGNITION & PROVIDE MAXIMUM
VENTILATION. EQUIP PERSONAL W/PROPER RESPIRATORY, SKIN & EYE
PROTECTION. TAKE UP MATERIAL W/SAWDUST, VERMICULITE/OTHER ABSORBENT
MATERIAL & PLACE IN CONTAI NERS FOR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS TIGHTLY CLOSED.
ISOLATE FROM HEAT, ELECTRICAL EQUIPMENT, SPARKS & OPEN FLAMES.
Other Precautions:TOXIC GASES MAY FORM WHEN PRODUCT IS CONTACTED BY
FLAME/HOT SURFACES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR NIOSH/MSHA APPROVED (TC-23-C) PAINT
SPRAY/(TC-19-C) AIR SUPPLIED RESPIRATOR.
Ventilation:GENERAL DILUTION/LOCAL EXHAUST IN VOLUME & PATTERN TO KEEP
THE CONCENTRATION OF INGREDIENTS BELOW EXPOSURE LIMITS.
Other Protective Equipment:PROTECTIVE CLOTHING, APRON.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:<0F
Vapor Pres:<78
Vapor Density:>1
Spec Gravity:0.7-0.8
Evaporation Rate & Reference:(BU O AC = 100): <57
Solubility in Water:21-4%
Percent Volatiles by Volume:85-96
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ALKALIES, STRONG MINERAL ACIDS & STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT, SPARKS & OPEN FLAMES.
Hazardous Decomposition Products:CO, CO2.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS. DON'T INCINERATE CLOSED CONTAINERS. UN1954.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SIMPLEX MULTI-PURPOSE CLEANER SX #15931
Kit Part:Y
CAGE:0DAC4
CAGE:0DAC4
CAGE:85884
============= Composition/Information on Ingredients =============
Ingred Name:PROPASOL P
CAS:1569-01-3
RTECS #:UB9351000
Fraction by Wt: 21.5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:AMMONIUM HYDROXIDE (CERCLA)(SARA 313)
CAS:1336-21-6
RTECS #:BQ9625000
Fraction by Wt: <4.5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:35 MG/M3
ACGIH TLV:STEL 24 MG/M3
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: CAUSES IRRITATION. SKIN: MAY
CAUSE IRRITATION DEPENDING ON DEGREE EXPOSURE. INGESTION: CAN CAUSE
IRRITATION/NAUSEA/STOMACH DISTRESS. INHALATION: CAN CAUSE
IRRITATION TO MOUTH/THROAT/AIRWAYS, ESPE CIALLY FOR SENSITIVE
PEOPLE.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH IMMED W/LOTS COOL RUNNING WATER. REMOVE CONTACTS &
FLUSH AGAIN. SKIN: FLUSH W/WATER THEN WASH W/SOAP & WATER.
INGESTION: RINSE MOUTH. DRINK 1-2 LARGE GLASSES WATER. DON'T INDUCE
VOMITING. N EVER GIVE ANYTHING BY MOUTH TO UNCONSCIOUS PERSON.
INHALATION: REMOVE TO FRESH AIR. IF INGESTED/PERSISTENT EYE/SKIN
IRRITATION CALL POISON CONTROL OR DR IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:108F,42C
Fire Fighting Procedures:PRODUCT DOES NOT SUPPORT COMBUSTION.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:DIKE/DAM LARGE SPILLS. PUMP TO CONTAINERS OR
SOAK UP ON INERT ABSORBENT. FLUSH RESIDUE TO SANITARY SEWER.
RECOVER MATERIAL IF POSSIBLE.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP DRY. DON'T STORE IN WET OR MOIST
AREA.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AVOID BREATHING MISTS OR VAPORS OF THIS PRODUCT.
Supplemental Safety and Health
*PH = 11.2-12.5
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>212F,>100C
Spec Gravity:1.021
pH:*
Solubility in Water:COMPLETE
Appearance and Odor:BRIGHT YELLOW COLOR, LEMON - AMMONIA ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NK
Stability Condition to Avoid:DO NOT MIX WITH ANYTHING BUT WATER.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONSULT STATE, LOCAL AUTHORITIES FOR
RESTRICTIONS ON DISPOSAL OF CHEMICAL WASTE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SIFCO DALIC SOLUTION NO.2 ETCHING AND ACTIVATING,CODE 1022
CAGE:11924
CAGE:11924
============= Composition/Information on Ingredients =============
Ingred Name:HYDROCHLORIC ACID
CAS:7647-01-0
RTECS #:MW4025000
Minumum % Wt:3.
Maxumum % Wt:7.
OSHA PEL:C7 MG/M3;C5 PPM
ACGIH STEL:C7.5 MG/M3;C5 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Minumum % Wt:93.
Maxumum % Wt:97.
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYE: CORROSIVE TO EYES AND MAY
CAUSE SEVERE EYE DAMAGE. SKIN CONTACT: CAUSES IRRITATION. MAY CAUSE
SKIN BURNS. SKIN ABSORPTION: SUBSTANCE DOES NOT ABSORB THROUGH
SKIN. INHALATION: IRRITATING TO EYES, NOSE, THROAT, AND LUNGS, MAY
CAUSE SNEEZING, WATERING OF EYES, NASAL DISCHARGE, COUGHING.
INGESTION: SALTY BITTER TASTE. MAY CAUSE GASTROINTESTINAL
IRRITATION WITH HEARTBURN, NAUSEA, AND VOMITI NG. CHRONIC EFFECTS:
PROLONGED OR REPEATED EXPOSURE MAY CAUSE EROSION OF TEETH,
BRONCHIAL IRRITATION AND GASTROINTESTINAL DISTURBANCES. TARGET
ORGANS: SKIN, EYES, RESPIRATORY SYSTEM.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:PREEXISTING SKIN AND EYE
CONDITIONS; RESPIRATORY SYSTEM DISORDERS.
======================= First Aid Measures =======================
First Aid:FIRST AID PROVIDERS MUST TAKE PROPER PRECAUTIONS FOR THEIR
OWN SFTY BEFORE ENTERING CONTAMD AREAS TO ASSIST CHEM ACCIDENT
VICTIMS & HNDLG THEIR CONTAMD CLTHG & EQUIP. ANOTHER PERSON SHOULD
IMMED CALLEMER MED SERVICE, 911-OPERATOR, HOSPITAL, PHYS,
OPHTHALMOLOGIST/POIS CTL CTR, AS APPLIC. GIVE FOLLOWING INFO:
OF CHEM AGENT & PROD, NU MBER & CNDTN OF CASUALTIES, WHAT IS BEING
VICTIM FROM CONTAMD AREA TO CLEAN, QUIET, (SUPDAT)
===================== Fire Fighting Measures =====================
Lower Limits:NONE
Upper Limits:NONE
Extinguishing Media:ALL. MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:CONTACT WITH METALS MAY FORM FLAMMABLE
HYDROGEN GAS. CONTAINERS CAN BUILD UP PRESSURE AND BURST IF EXPOSED
TO HEAT (FIRE). WATER RUNOFF CAN CAUSE ENVIRONMENTAL DAMAGE. DIKE
AREA FOR LATER DISPOSAL.
================== Accidental Release Measures ==================
Spill Release Procedures:DO NOT TOUCH/WALK THROUGH SPILLED MATL.
ISOLATE HAZ AREA & KEEP PEOPLE AWAY. NOTIFY YOUR FACILITY EMER
COORDINATOR. ELIM ALL SOURCES OF IGNIT. PROVIDE MAX VENT. DO NOT
RELEASE INTO SOIL, SEWERS/NATRL BODIES OF WATER. WEAR PROPER
PERSONAL PROT EQUIP (PPE). CAREFULLY MOP UP/VACUUM SPILL & TRIPLE
RINSE W/WATER INTO SUITABLE PLASTIC CNTNR. RELEASE OF REPORTABLE
QTY (RQ) REQS NOTIFICATION (OTHER INFO)
Neutralizing Agent:SODIUM BICARBONATE SODA ASH/SLAKED LIME.
======================Handling and Storage ======================
Handling and Storage Precautions:USE "BUDDY SYSTEM" WHEN WORKING WITH
CHEMICALS. DO NOT GET IN EYES, ON SKIN, ON CLOTHING. DO NOT BREATHE
VAPOR, MIST OR GAS. USE W/ADEQUATE VENTILATION. WASH THOROUGHLY
AFTER HANDLING. TRIPLE RINSE CO NTAINER CLEAN BEFORE DISCARDING.
PUT NOTHING ELSE IN THIS CONTAINER.
Other Precautions:KEEP CONTAINER TIGHTLY CLOSED IN UPRIGHT POSITION.
STORE AT 60-90F AWAY FROM INCOMPATIBLE MATERIALS AND PHYSICAL
HAZARDS. DO NOT REMOVE OR DEFACE CONTAINER LABELS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF ENGINEERING CONTROLS ARE NOT FEASIBLE, THE
RESPIRATORY PROTECTION PROGRAM MUST COMPLY WITH OSHA'S 29 CFR
1910.134, 30 CFR 11 AND ANSI Z88.2 REQUIREMENTS. NIOSH APPROVED
RESPIRATOR APPROPRIATE FOR E XPOSURE OF CONCERN .
Ventilation:LOCAL EXHAUST VENTILATION IS REQUIRED TO MEET THE
PERMISSIBLE EXPOSURE LIMITS (PEL) DURING THE USE OF THIS PRODUCT.
FACESHIELD .
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
IMPERVIOUS BOOTS, APRON, PROTECTIVE CLOTHING AS REQUIRED BY JOB
CONDITIONS.
Work Hygienic Practices:DO NOT WEAR CONTACT LENSES. WASH THOROUGHLY
AFTER HANDLING.
Supplemental Safety and Health
FIRST AID PROC: VENTILATED AREA. CALM & REASSURE HIM, KEEP HIM WARM.
EYES: HOLD EYELIDS APART & FLUSH W/PLENTY OF WATER FOR AT LST 15
MINS. SKIN: IMMED FLUSH W/PLENTY OF WATER FOR AT LST 15 MINS WHILE
REMOVING CONTAMD CLTHG & SHOES. THOROUGHLY DECONTAMINATE(OR
DISCARD) CLTHG & SHOES. (OTHER INFORMATION)
================== Physical/Chemical Properties ==================
Boiling Pt:>100.C, 212.F
B.P. Text:>100C;>212F
Melt/Freeze Pt:<0.C, 32.F
M.P/F.P Text:<0C;<32F
Spec Gravity:1.083-1.093
pH:0-1
Evaporation Rate & Reference:<1 (ETHYL ETHER =1)
Solubility in Water:COMPLETE
Appearance and Odor:LIGHT YELLOW LIQUID, NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH REACTIVE METALS, STRONG BASES, OXIDIZERS.
Stability Condition to Avoid:STABLE UNDER NORMAL AMBIENT CONDITIONS.
Hazardous Decomposition Products:HCL*2, CL*2, H*2.
=================== Toxicological Information===================
Toxicological Information:NOT AVAILABLE.
===================== Ecological Information =====================
Ecological:ENVIRONMENTAL HAZARD.
==================== Disposal Considerations ====================
Waste Disposal Methods:SHIP TO APPRVD TREATMENT/DISP FACILITY. DISPOSE
OF ACCORDING TO LOCAL, STATE, AND FEDERAL REGS. EPA WASTE I.D.
NUMBER: D002. FOLLOW APPLIC REGS FOR DISP OF EMPTY CNTNRS &
RINSATE. DISP INFO APPLIES TO MATL MANUFACTURED. CONTAM MAY AFFECT
DISP REQUIREMENTS. RESPONSIBILITY FOR PROPER WASTE DISP IS W/G
ENERATOR OF WASTE.
=================== MSDS Transport Information ===================
Transport Information:DOT, IATA, ICAO, IMO DESCRIPTION: PROPER SHIPPING
NAME: HYDROCHLORIC ACID SOLUTION. HAZARD CLASS: 8. IDENTIFICATION
NUMBER: UN 1789. PACKAGING GROUP (PG): II. LABEL REQUIREMENTS: 8 -
CORROSIVE. UNIT C ONTAINER: 1 LITER, 4 LITER POLYETHYLENE BOTTLE.
PACKAGING: MEETS PERFORMANCE ORIENTED PACKAGING REQUIREMENTS.
REPORTABLE QUANTITY (RQ): >10,000 LITERS. 1996 NAERG GUIDE#: 157.
===================== Regulatory Information =====================
SARA Title III Information:SUPPLIER NOTIFICATION ABOUT TOXIC CHEMICALS:
SIFCO SELECTIVE PLATING IS REQD TO INFORM YOU, THAT THIS PROD CNTNS
TOXIC CHEMS SUBJECT TO RPTG REQUIREMENTS OF SECTION 313 OF TITLE
III OF SUPERFUND AMEND MENTS & REAUTHORIZATION ACT OF 1986 & 40 CFR
PART 372, IF SPECIFIED ANNUAL THRESHOLDS ARE MET OR EXCEEDED. TOXIC
CHEM: HYDROCHLORIC ACID, CAS# 7647-01-0, WT%(MAX): 7. YOUR OTHER
SUPPLIERS OF TRADE NAM E PRODS/MIX CNTNG SECTION 313 CHEMS MUST
ALSO NOTIFY YOU. IF YOU REPACKAGE/OTHERWISE REDISTRIBUTE THIS PROD
TO INDUST CUSTOMERS YOU ARE REQD TO FURNISH SIMILAR NOTIFICATION TO
THEM.
Federal Regulatory Information:CERCLA & EPCRA: THRESHOLD PLANNING QTY:
>100,000 LITERS. (RELEASE) REPORTABLE QTY: >10,000 LITERS.
EXTREMELY HAZ SUBSTANCE: NONE. EPCRA HAZ CATEGORIES: IMMED (ACUTE)
HLTH: YES. DELAYED (CHRONIC) HLTH:YES. FIRE: NO. SUDDEN RELEASE
OF PRESS:NO. REACTIVITY:NO. TSCA STATEMENT: ALL INGREDS OF PROD ARE
LISTED UNDER TOXIC SUBSTANCES CONTROL ACT (TSCA). ODS
CERTIFICATION: PROD DOES NOT CNTN & IS NOT MFRD W/OZONE DEPLETING
SUBSTANCES (ODS). VOC CERTIFICATION: PROD DOES NOT CNTN ANY
VOLATILE ORG CMDPS (V OC). PCB CERTIFICATION: PROD DOES NOT CNTN
ANY POLYCHLORINATED BIPHENYLS (PCB).
State Regulatory Information:STATE REGULATIONS: CALIFORNIA PROP 65: NOT
APPLICABLE. INTERNATIONAL REGULATIONS: WHMIS CLASSIFICATION: CLASS
E, CLASS D2B.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CAL-2065, 1426
Preparer's Name:R. C. JENTE
CAGE:21667
CAGE:21667
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM ALKYL (ETHER) SULFATE. LD50: (ORAL,RAT)10.2 G/KG
Fraction by Wt: 6%
Ingred Name:ACETIC ACID, NITRILOTRI-, TRISODIUM SALT, MONOHYDRATE;
(NITRILOTRIACETIC ACID SODIUM SALT)
CAS:18662-53-8
RTECS #:AJ1070000
Fraction by Wt: 15%
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENT 1
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES: CAUSES EYE IRRITATIONS.
SUBCHRONIC, CHRONIC: THIS PRODUCT CONTAINS NITRILOTRIACETIC ACID
(NTA) CAS# 18662-53-8, WHICH HAS BEEN DETERMINED TO CAUSE CANCER
WHEN FED TO SOME LAB ANIMALS.
Explanation of Carcinogenicity:NITROLOTRIACETIC ACID, TRISODIUM SALT,
MONOHYDRATE: GROUP 2B (IARC);NTP GROUP 2.
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: IN CASE OF CONTACT, IMMEDIATELY FLUSH EYES WITH PLENTY
OF WATER FOR AT LEAST 15 MIN. CALL A PHYSICIAN. SKIN: FLUSH WITH
COPIOUS AMOUNTS OF WATER. CALL MD. . INHAL: REMOVE TO FRESH AIR.
SUP PORT BREATHING (GIVE ARTF RESP/O*2) INGEST: GET MD IMMEDIATELY
.
===================== Fire Fighting Measures =====================
Flash Point:NOT FLAMMABLE
Extinguishing Media:PRODUCT IS NOT FLAMMABLE.
Fire Fighting Procedures:AS WITH ANY CHEMICAL FIRE, FIREFIGHTERS SHOULD
TAKE SPECIAL PRECAUTIONS. A NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT IS ESSENTIAL.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:DIKE AREA, CONTAIN AS MUCH SPILLED MATERIAL
POSSIBLE. REMOVE ANY REMAINING MATERIAL ABSORBING ON VERMICULITE OR
OTHER SUITABLE MATERIAL AND PLACE IN A SEALED METAL CONTAINER FOR
DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTACT WITH EYES. KEEP
CONTAINER CLOSED.
Other Precautions:READ AND OBSERVE ALL LABELED PRECAUTIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED.
Ventilation:NORMAL
Other Protective Equipment:NOT REQUIRED.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:B3
Boiling Pt:B.P. Text:>212F,>100C
Vapor Pres:LIKE H*2O
Vapor Density:LIKE H*2O
Spec Gravity:1.12
pH:11
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR GREEN LIQUID, PERFUME ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS, STRONG OXIDIZERS.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:UNKNOWN.
==================== Disposal Considerations ====================
Waste Disposal Methods:MIX WITH A FLAMMABLE SOLVENT AND INCINERATE IN
ACCORDANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:LEAD-ACID BATTERY
CAGE:IO592
CAGE:IO592
CAGE:0W0V7
============= Composition/Information on Ingredients =============
Ingred Name:LEAD (SARA 313) (CERCLA)
CAS:7439-92-1
RTECS #:OF7525000
Fraction by Wt: 60%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:SEE 1910.1025
ACGIH TLV:0.05MG/M3, A3; 9596
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:ANTIMONY (SARA 313) (CERCLA)
CAS:7440-36-0
RTECS #:CC4025000
Fraction by Wt: 2%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.5 MG/M3
ACGIH TLV:0.5 MG (SB)/M3; 9596
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ARSENIC (SARA 313) (CERCLA)
CAS:7440-38-2
RTECS #:CG0525000
Fraction by Wt: 0.2%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:SEE 1910.1018
ACGIH TLV:0.01 MG/M3, A1; 9596
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:CALCIUM, METAL
CAS:7440-70-2
RTECS #:EV8040000
Fraction by Wt: 0.2%
Other REC Limits:NONE RECOMMENDED
Ingred Name:TIN
CAS:7440-31-5
RTECS #:XP7320000
Fraction by Wt: 0.2%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3; 9596
Ingred Name:SULFURIC ACID (SARA 302/313) (CERCLA)
CAS:7664-93-9
RTECS #:WS5600000
Fraction by Wt: 10-30%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3/3 STEL; 9596
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:POLYPROPYLENE (INGREDIENTS 7-15 EQUAL 5-10%)
CAS:9003-07-0
RTECS #:TR5000000
Other REC Limits:NONE RECOMMENDED
Ingred Name:POLYSTYRENE (INGREDIENTS 7-15 EQUAL 5-10%)
CAS:9003-53-6
RTECS #:WL6475000
Other REC Limits:NONE RECOMMENDED
Ingred Name:STYRENE ACRYLONITRILE (INGREDIENTS 7-15 EQUAL 5-10%)
CAS:9003-54-7
RTECS #:AT6978000
Other REC Limits:NONE RECOMMENDED
Ingred Name:ACRYLONITRILE-BUTADIENE-STYRENE TERPOLYMER (INGREDIENTS
7-15 EQUAL 5-10%)
CAS:9003-56-9
RTECS #:AT6970000
Other REC Limits:NONE RECOMMENDED
Ingred Name:BUTADIENE-STYRENE POLYMER (RUBBER) (INGREDIENTS 7-15 EQUAL
5-10%)
CAS:9003-55-8
RTECS #:WL6478000
Other REC Limits:NONE RECOMMENDED
Ingred Name:POLYVINYL CHLORIDE (INGREDIENTS 7-15 EQUAL 5-10%)
CAS:9002-86-2
RTECS #:KV0350000
Other REC Limits:NONE RECOMMENDED
Ingred Name:POLYCARBONATE (INGREDIENTS 7-15 EQUAL 5-10%)
Other REC Limits:NONE RECOMMENDED
Ingred Name:RUBBER (INGREDIENTS 7-15 EQUAL 5-10%)
Other REC Limits:NONE RECOMMENDED
Ingred Name:POLYETHYLENE (INGREDIENTS 7-15 EQUAL 5-10%)
RTECS #:PM9002884
Other REC Limits:NONE RECOMMENDED
Ingred Name:SILICA, CRYSTALLINE - FUSED
CAS:60676-86-0
RTECS #:VV7328000
Fraction by Wt: 10%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:SEE TABLE Z-3
ACGIH TLV:0.1 MG/M3 RDUST;9596
Ingred Name:POLYETHYLENE
RTECS #:PM9002884
Fraction by Wt: NP
Other REC Limits:NONE RECOMMENDED
Ingred Name:SHEET MOLDING COMPOUND (GLASS-REINFORCED POLYESTER)
Fraction by Wt: 10%
Other REC Limits:NONE RECOMMENDED
Ingred Name:INORG PB/H2SO4 PRIMARY COMPO OF EVERY YUASA-EXIDE INC MFG
BATT.OTHER INGREDS MAY BE PRESENT DEPENDENT UPON BATTY TYPE.
Fraction by Wt: NA
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:SULFURIC ACID: HARMFUL BY ALL ROUTES
OF ENTRY. HAZARDOUS EXPOSURE TO LEAD CAN OCCUR ONLY WHEN PRODUCT IS
HEATED, OXIDIZED, OR OTHERWISE PROCESSED OR DAMAGED TO CREATE DUST,
VAPOR OR FUME.
Explanation of Carcinogenicity:CONTAINS ARSENIC [7440-38-2] WHICH IS
LISTED BY NTP AND IARC AND REGULATED BY OSHA AS CARCINOGEN & LEAD &
SULFURIC ACID
Effects of Overexposure:SEVERE RESPIRATORY IRRITATION, SEVERE
IRRITATION OF MOUTH, THROAT, ESOPHAGUS, STOMACH, ABDOMINAL PAIN,
NAUSEA, VOMITING, DIARRHEA, SEVERE CRAMPING, SEVERE SKIN
IRRITATION/BURNS/ULCERATION, SEVERE EYE IRRITATION/BURNS/CORNEA
DAMAGE/BLINDNESS, ANEMIA, NEUROPATHY, KIDNEY DAMAGE, REPRODUCTIVE
CHANGES.
Medical Cond Aggravated by Exposure:OVEREXPOSURE TO SULFURIC ACID MIST
MAY CAUSE LUNG DAMAGE AND AGGRAVATE PULMONARY CONDITIONS. CONTACT
W/SKIN MAY AGGRAVATE ECZEMA, CONTACT DERMATITIS. MAY AGGRAVATE
KIDNEY,LIVER OR NEUROLOGIC DISEASES.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR 15 MINUTES WHILE HOLDING EYELIDS
OPEN. GET MEDICAL ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING.
WASH WITH SOAP AND WATER. IF IRRITATION PERSIST, GET MEDICAL
ATTENTION. INH ALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. GET
MEDICAL ATTENTION. INGESTION: DO NOT INDUCE VOMITING. GIVE 1-2
GLASSES OF WA TER IF CONSCIOUS. GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONCOMBUSTIBLE
Lower Limits:4.1 (H2)
Upper Limits:74.2
Extinguishing Media:CARBON DIOXIDE, FOAM, DRY CHEMICAL
Fire Fighting Procedures:IF BATTERIES ARE ON CHARGE, SHUT OFF POWER.
USE POSITIVE PRESSURE, SELF-CONTAINED BREATHING APPARATUR. WATER
APPLIED TO ELECTROLYTE GENERATES HEAT AND SPLATTERS
Unusual Fire/Explosion Hazard:HIGHLY FLAMMABLE HYDROGEN GAS IS
GENERATED DURING CHARGING AND OPERATION OF BATTERIES. TO AVOID RISK
OF FIRE KEEP SPARKS OR OTHER IGNITION SOURCES AWAY.
================== Accidental Release Measures ==================
Spill Release Procedures:STOP FLOW OF MATERIAL. CONTAIN/ABSORB SMALL
SPILLS WITH DRY SAND, EARTH, VERMICULITE. DO NOT USE COMBUSTIBLE
MATERIALS. IF POSSIBLE, CAREFULLY NEUTRALIZE SPILLED ELECTROLYTE.
Neutralizing Agent:SODA ASH, SODIUM BICARBONATE, LIME
======================Handling and Storage ======================
Handling and Storage Precautions:STORE BATTERIES IN COOL, DRY,
WELL-VENTILATED AREAS WITH IMPERVIOUS SURFACES AND ADEQUATE
CONTAINEMENT IN THE EVENT OF A SPILL.
Other Precautions:BATTERIES SHOULD BE STORED UNDER ROOF FOR PROTECTION
AGAINST ADVERSE WEATHER CONDITIONS. STORE AND HANDLE ONLY IN AREAS
WITH ADEQUATE WATER SUPPLY AND SPILL CONTROL. AVOID DAMAGE TO
CONTAINERS. KEEP A WAY FROM FIRE, SPARKS AND HEAT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED UNDER NORMAL CONDITIONS. WHEN
CONCENTRATIONS OF SULFURIC ACID MIST ARE KNOWN TO EXCEED PEL, USE
NIOSH OR MSHA-APPROVED RESPIRATORY PROTECTION.
Ventilation:IF MECHANICAL VENTILATION IS USED, COMPONENTS MUST BE
ACID-RESISTANT.
Other Protective Equipment:ACID RESISTANT APRON. UNDER SEVERE EXPOSURE
OR EMERGENCY CONDITIONS, WEAR ACID-RESISTANT CLOTHING AND BOOTS.
Work Hygienic Practices:IN AREAS WHERE SULFURIC ACID IS HANDLED IN
CONCENTRATIONS > 1%, EMERGENCY EYEWASH STATION AND SHOWERS SHOULD
BE PROVIDED
Supplemental Safety and Health
DO NOT ALLOW METALLIC MATERIALS TO SIMULTANEOUSLY CONTACT NEGATIVE AND
POSITVE TERMINALS OF CELLS AND BATTERIES. FOLLOW MANUFACTURER'S
INSTRUCTIONS FOR INSTALLATION AND SERVICE.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:203F,95C
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Vapor Pres:10
Vapor Density:>1
Spec Gravity:1.215 TO 1.350
Evaporation Rate & Reference:< 1 (BUTYL ACETATE = 1)
Solubility in Water:COMPLETE
Appearance and Odor:MANUFACTURED ARTICLE, NO APPARENT ODOR. ELECTROLYTE
IS CLEAR LIQUID, SHARP ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
SULFURIC ACID: COMBUSTIBLES, ORGANIC MATERIALS, STRONG REDUCING AGENTS,
METALS, SULFUR TRIOXIDE GAS, STRONG OXIDIZERS
Stability Condition to Avoid:PROLONGED OVERCHARGE; SOURCES OF IGNITION;
WATER.
Hazardous Decomposition Products:DECOMPOSITION OF SULFURIC ACID
RELEASES SULFUR TRIOXIDE, CARBON MONOXIDE, SULFURIC ACID FUME,
SULFUR DIOXIDE, HYDROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT ALLOW DISCHARGE OF UNNEUTRALIZED ACID TO
SEWER. SEND SPENT BATTERIES TO SECONDARY LEAD SMELTER FOR
RECYCLING. PLACE NEUTRALIZED SLURRY INTO SEALED CONTAINERS AND
DISPOSE OF AS HAZARDOUS WASTE A S APPLICABLE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PIPE JOINT COMPOUND
CAGE:88450
CAGE:88450
============= Composition/Information on Ingredients =============
Ingred Name:NON-HAZARDOUS INGREDIENTS
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE/CHRONIC: NONE SPECIFIED BY
MANUFACTURER.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGESTION: DO NOT INDUCE VOMITING. CONSULT MD IMMEDIATELY.
EYES: FLUSH WITH WATER FOR AT LEAST 15 MINUTES. SKIN: WIPE OFF AND
WASH WITH SOAP AND WATER. CONSULT MD IF IRRITATION DEVELOPS.
INHALATION: R EMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE OXYGEN OR
ARTIFICIAL RESPIRATION) .
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:250F,121C
Extinguishing Media:USE DRY CHEMICAL OR CARBON DIOXIDE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:WIPE UP WITH RAGS, WASH WITH SOAP AND WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A DRY, COOL PLACE.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED. USE NIOSH/MSHA APPROVED RESPIRATOR
APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:NORMAL VENTILATION.
Other Protective Equipment:EMERGENCY EYEWASH & DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:400F,204C
Melt/Freeze Pt:M.P/F.P Text:2%
Spec Gravity:1.87 (H*2O=1)
Solubility in Water:5%
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ALKYD PRIMER,RED, 67Y-746(781226)
CAGE:DO229
CAGE:18873
CAGE:DO229
============= Composition/Information on Ingredients =============
Ingred Name:ALIPHATIC PETROLEUM DISTILLATE
Fraction by Wt: 16.0%
ACGIH TLV:100 PPM(PER MFR
Ingred Name:ZINC (SARA III)
CAS:7440-66-6
RTECS #:ZG8600000
Fraction by Wt: 8.36%
OSHA PEL:10 MG ZNO/M3
ACGIH TLV:10 MG ZNO/M3; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:CHROMIUM (III) OXIDE
CAS:1308-38-9
RTECS #:GB6475000
Fraction by Wt: 12.3%
OSHA PEL:0.5 MG/M3 (CR)
ACGIH TLV:0.5 MG/M3 (CR); 8990
Ingred Name:LEAD (SARA III)
CAS:7439-92-1
RTECS #:OF7525000
Fraction by Wt: 0.34%
OSHA PEL:0.05 MG/M3;1910.1025
ACGIH TLV:0.15 MG/M3;DUST 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:MANGANESE (SARA III)
CAS:7439-96-5
RTECS #:OO9275000
Fraction by Wt: 0.03%
OSHA PEL:(C) 5 MG/M3 DUST
ACGIH TLV:5 MG/M3 DUST 9293
===================== Hazards Identification =====================
Effects of Overexposure:CAUSES HEADACHE,NAUSEA,IMPAIRMENT OF REACTION
TIME AND COORDINATION.
======================= First Aid Measures =======================
First Aid:INHALATION:MOVE TO FRESH AIR TO IMPROVE BREATHING;SKIN:WASH
WITH SOAP & WATER.REMOVE CONTAMINATED CLOTHING;EYES:FLUSH WITH
WATER FOR AT LEAST 15 MIN.CALL A PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:100-140F (CC)
Lower Limits:1.0
Upper Limits:7.0
Extinguishing Media:CO*2, FOAM, DRY CHEM.
Fire Fighting Procedures:COOL CLOSED CONTNRS W/H*20 USING FOG NOZZLES.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE UNPROTECTED PERSONS. ELIM IGNITION
SOURCES. STOP LEAK. H*2O SPRAY COOL CONT/DIVERT SPILL FROM
FIRE/HEAT. PROVIDE VENTILATION. ABSORB W COMMERCIAL
ABSORBENT,SHOVEL INTO METAL DRUMS:LG SPILL:DI KE W COMMERCIAL
ABSORBENT,PUMP INTO COVERED DRUMS.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT,SPARKS & OPEN
FLAMES.CLOSE CONTAINERS AFTER EACH USE.DO NOT STORE ABOVE
120F;REMOVE IGNITION SOURCES,AS SPECIAL VENTILATION.
Other Precautions:WASH THOROUGHLY AFTER HANDLING ANDBEFORE EATING OR
SMOKING;OBSERVE LABEL PRECAUTIONS;CONTAINERS SHOULD BE GROUNDED
WHEN POURING.AVOID PROLONGED SKIN CONTACT & BREATHING VAPOR IN
SPILL CLEANUP
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA RESP TC-23C IF AIR CONTMNANTS
CONTROL IS NOT FEASIBLE
Ventilation:LOCAL & MECH PROVIDE SUFFICIENT VENT TO KEEP BELOW TLV
LEVEL
Other Protective Equipment:USE APPROPRIATE INDUSTRIAL HYGIENE
PRACTICES.
Supplemental Safety and Health
MSDS FM MFR DATED:10/23/80;VAPOR PRESSURE/DENSITY NOTED OF PRINCOPAL
SOLVENT;NIOSH 6:1001272UC,UNIDENTIFIED COMPONENTS,%WT BY
DIFFRNCE:62.97%,TLV UNK(PER MFR,DOES NOT CONTAIN H*20).
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:293-410
Vapor Pres:10
Vapor Density:3.9
Spec Gravity:1.620
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NEGLIGIBLE
Appearance and Odor:LIQUID PRIMER WITH CHARACTERISTIC ODOR.
Percent Volatiles by Volume:34.1
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS, CORROSIVES
Stability Condition to Avoid:HEAT, IGNITION SOURCES
Hazardous Decomposition Products:CO,CO*2,SMOKE,OXIDES OF
ZINC,LEAD,CRO3(OXIDES OF CHROMIUM).
==================== Disposal Considerations ====================
Waste Disposal Methods:KEEP IN COVERED DRUMS,PENDING DISPOSAL. HANDLE &
DISPOSE IN FULL COMPLIANCE WITH ALL APPLICABLE
INTERNATIONAL,FEDERAL,STATE, & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:HELIUM-4 ATOMIC HELIUM
CAGE:AIRGA
CAGE:AIRGA
CAGE:0MN39
============= Composition/Information on Ingredients =============
Ingred Name:ING 14:WILL REQ EMER TREATMENT. IF CONT W/LIQUEFIED/HIGH
PRESS COMPRESSED GAS OCCURS, WASH W/WATER FOR @ LST (ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15:15 MINS & GET MED ATTN IMMED. INGEST:IT IS UNLIKELY
THAT EMER TREATMENT WILL BE REQD. IF ADVERSE EFTS (ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16:OCCUR, TREAT SYMPTOMATICALLY & SUPPORTIVELY & GET
MED ATTN. ANTIDOTE:TREAT SYMPTOMATICALLY & SUPPORTIVELY.
RTECS #:9999999ZZ
Ingred Name:WASTE DISP METH:WHICH ARE REMOTE FROM PERSONNEL, WORK
AREAS, AND BUILDING AIR INTAKES.
RTECS #:9999999ZZ
Ingred Name:RESP PROT:ANY NIOSH APPRVD SCBA. FOR FIREFIGHTING & OTHER
IMMED DANGEROUS TO LIFE/HLTH CNDTNS:NIOSH APPRVD SCBA (ING 20)
RTECS #:9999999ZZ
Ingred Name:ING 19:W/FULL FACEPIECE OPERATED IN PRESS-DEMAND OR OTHER
POSITIVE PRESS MODE. NIOSH APPRVD SUPPLIED-AIR RESP (ING 21)
RTECS #:9999999ZZ
Ingred Name:ING 20:RESP W/FULL FACEPIECE & OPERATED IN
PRESS-DEMAND/OTHER NIOSH APPRVD POS PRESS MODE IN COMBINATION WITH
(ING 22)
RTECS #:9999999ZZ
Ingred Name:ING 21:AUXILIARY SCBA OPERATED IN PRESSURE-DEMAND/OTHER
POSITIVE PRESSURE MODE.
RTECS #:9999999ZZ
Ingred Name:HELIUM
CAS:7440-59-7
RTECS #:MH6520000
Fraction by Wt: <99.9%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:OXYGEN
CAS:7782-44-7
RTECS #:RS2060000
Fraction by Wt: <0.1%
OSHA PEL:C 0.05 PPM
ACGIH TLV:C 0.05 PPM
Ingred Name:NITROGEN
CAS:7727-37-9
RTECS #:QW9700000
Fraction by Wt: 0.1%
OSHA PEL:N/K
ACGIH TLV:ASPHYXIANT
Ingred Name:NEON
CAS:7440-01-9
RTECS #:QP4450000
Fraction by Wt: O.1%
OSHA PEL:N/K
ACGIH TLV:ASPHYXIANT
Ingred Name:SUPDAT:SUITABLE FOR TYPE OF FIRE. COOL CNTNRS W/FLOODING
AMTS OF WATER, APPLY FROM AS FAR A DISTANCE AS POSSIBLE.
RTECS #:9999999ZZ
Ingred Name:EFTS OF OVEREXP:PROGRESSES, NAUS, VOMIT, COLLAPSE, UNCON,
CONVULSIONS, DEEP COMA & DEATH ARE POSS. SKIN: NO (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6:ADVERSE EFTS HAVE BEEN RPTD FROM GAS. CONT
W/CRYOGENIC LIQ WILL CAUSE FROSTBITE W/REDNESS, TINGLING & PAIN
(ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7:OR NUMBNESS. IN MORE SEV CASES, SKIN MAY BECOME HARD
& WHITE & DEVELOP BLISTERS. EYE: NO ADVERSE EFTS HAVE (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8:BEEN RPTD FROM GAS. CONT W/CRYOGENIC LIQ MAY CAUSE
FROSTBITE W/REDNESS, PAIN, & BLURRED VISION. INGEST: (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9:INGEST OF GAS IN UNLIKELY. IF LIQ IS SWALLOWED,
FROSTBITE DMG TO LIPS, MOUTH & MUC MEMB MAY OCCUR.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC:GET MED ATTN. IN CASE OF CONT W/CRYOGENIC
LIQ, TREAT FOR FROSTBITE. WARM AFFECTED SKIN W/WATER (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11:AT TEMP NOT >107F. IF WATER IS NOT AVAIL/IMPRACTICAL
TO USE, GENTLY WRAP AFFECTED PART IN BLANKETS. (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12:ENCOURAGE VICTIM TO EXERCISE AFFECTED PART WHILE IT
IS BEING WARMED. ALLOW CIRCULATION TO RETURN (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13:NATURALLY. GET MED ATTN IMMED. EYE:IT IS UNLIKELY
THAT CONT W/GAS @ ATMOSPHERIC PRESS & AMBIENT TEMP (ING 15)
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL: INHAL OF MIX OF HELIUM &
AIR/HELIUM & OXYG MAY CAUSE DISTORTED SPEECH, INCR LOSS OF BODY
HEAT, & GAS EMBOLI @ JUNCTION OF SKIN & SUBCUTANEOUS FAT/BODY FAT &
BLOOD VESS. SEE INFO ON SIMPL E ASPHYXIANTS. SIMPLE ASPHYXIANTS:
ACUTE: SYMPS OF ASPHXIA DEPEND ON RAPIDITY W/WHICH OXYG DEFICIENCY
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: DEVELOPS & HOW LONG IT CONTINUES. IN
SUDDEN ACUTE ASPHYXIA, UNCON MAY BE IMMED. W/SLOW DEVELOPMENT THERE
MAY BE RAPID RESPIRATION & PULSE, AIR HUNGER, DIZZ, REDUCED
AWARENESS, TIGHTNESS IN H EAD, TINGLING SENSATION, INCOORDINATION,
FAULTY JUDGEMENT, EMOTIONAL INSTABILITY, & RAPID FATIGUE. AS
ASPHYXIA (ING 6)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:IMMED REMOVE TO FRESH AIR. IF BRTHG HAS STOPPED, GIVE
ARTF RESP. MAINTAIN AIRWAY & BLOOD PRESS & ADMIN OXYG IF AVAIL.
KEEP AFFECTED PERSON WARM & @ REST. TREAT SYMPTOMATICALLY &
SUPPORTIVELY. AD MIN OF OXYG SHOULD BE PERFORMED BY QUALIFIED PERS.
GET MED ATTN IMMED. SKIN:WHERE CONT W/GAS @ AMBIENT TEMP IS
INVOLVED, IT IS UNLIKELY THAT EMER TREATMENT WILL BE REQD. IF
ADVERSE EFTS OCCUR,(ING 11)
===================== Fire Fighting Measures =====================
Extinguishing Media:DRY CHEM, CO*2/HALON. LARGER FIRES, USE WATER
SPRAY, FOG/STD FOAM(1993 EMER RESPONSE GUIDEBOOK, DOT-RSPA P
5800.6).
Fire Fighting Procedures:NIOSH APPRVD SCBA & FULL PROT EQUIP . MOVE
CNTNR FROM FIRE AREA IF POSS. STAY AWAY FROM STOR TANK ENDS. COOL
FIRE-EXPOSED CNTNRS W/WATER FROM (SUPDAT)
Unusual Fire/Explosion Hazard:NEGLIGIBLE FIRE HAZARD WHEN EXPOSED TO
HEAT/FLAME. CYLINDER MAY EXPLODE IN HEAT OF FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:STOP LEAK IF CAN BE DONE W/OUT RISK. KEEP
UNNECESSARY PEOPLE AWAY; ISOLATE HAZARD AREA AND DENY ENTRY.
VETILATE CLOSED SPACES BEFORE ENTERING.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:OBSERVE ALL FEDERAL, STATE & LOCAL
REGS WHEN STORING/DISPOSING OF THIS SUBSTANCE. STORE IN ACCORDANCE
W/29 CFR 1910.101.
Other Precautions:FOR ASSISTANCE, CONTACT DISTRICT DIRECTOR OF THE
ENVIRONMENTAL PROTECTION AGENCY. DO NOT PERMIT PHYSICAL
DMG/OVERHEATING OF CNTNRS. CONTENTS ARE UNDER PRESS; CNTNRS MAY
VIOLENTLY RUPTURE & TRAVEL CONS IDERABLE DISTANCE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:THE FOLLOWING RESPS ARE REC BASED ON INFO FOUND
IN PHYSICAL DATA, TOX & HLTH EFTS SECTIONS. THEY ARE RANKED IN
ORDER FROM MINIUM TO MAXIMUM RESP PROT. ANY NIOSH APPRVD
SUPPLIED-AIR RESP OPERATED IN PR ESS-DEMAND/OTHER POS PRESS
MODE.(ING 19)
Ventilation:PROVIDE GENERAL DILUTION VENTILATION.
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER . CONT
W/LIQ FORM WEAR APPROP PROT CLTHG & EQUIP TO PVNT SKIN FROM
FREEZING.
Work Hygienic Practices:CONTACT LENSES SHOULD NOT BE WORN.
Supplemental Safety and Health
SPEC GRAV (GAS):0.138 @ 70F, 1 ATM. VAP DENS (GAS):0.1650 G/L @ 70F, 1
ATM. FIRE FIGHT PROC:SIDE UNTIL WELL AFTER FIRE IS OUT. W/DRAW
IMMED IF RISING SOUND FROM VENTING SFTY DEVICE IS HEARD/ANY DISCOL
ORATION OF STOR TANKS DUE TO FIRE. (1993 EMER RESPONSE GUIDEBOOK,
DOT-RSPA P 5800.6, GUIDE NUMBER 12). USE AGENTS(ING 5)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:-452F,-269C
Melt/Freeze Pt:M.P/F.P Text:NONE
Vapor Density:SUPDAT
Spec Gravity:SUPDAT
Evaporation Rate & Reference:NOT KNOWN
Solubility in Water:0.0094 @ 0C
Appearance and Odor:NONFLAMMABLE, ODORLESS, COLORLESS, TASTELESS, INERT
GAS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NOT APPLICABLE.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NOT APPLICABLE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS . VENT HELIUM GAS SLOWLY TO WELL-VENTILATED OUTDOOR
LOCATION REMOTE FROM PERS, WORK AREAS, & BUILDING AIR INTAKES.
ALLOW LIQ HELIUM TO E VAP IN WELL-VENTILATED OUTDOOR LOCATIONS (ING
18)
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:T-10: HARDENER COMPONENT
Kit Part:Y
Preparer's Name:F. LOELOFF
CAGE:AMSAT
CAGE:88444
CAGE:AMSAT
============= Composition/Information on Ingredients =============
Ingred Name:PROPOXYLATED TRIETHYLENETETRAMINE
CAS:26950-63-0
Ingred Name:TRIETHYLENETETRAMINE
CAS:112-24-3
RTECS #:YE6650000
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: CAUSES SEVERE IRRIT AND BURNS.
SKIN: IRRITANT. MAY CAUSE SENSIT AND/OR ALLERGIC SKIN REACTION
WHICH CAN BE SEVERE IN CERTAIN INDIVIDUALS. INHALATION: CAUSES
UPPER RESPIRATORY TRACT IRRITATION AN D MUCOUS MEMBRANE IRRITATION.
INGESTION: NO SPECIFIC INFORMATION AVAILABLE. CONTAINS MATERIAL
THAT MAY BE SLIGHTLY TOX.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:IRRITATION, SENSITIZATION AND DERMATITIS.
Medical Cond Aggravated by Exposure:ALLERGY, ECZEMA AND OTHER SKIN
CONDITIONS.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH LRG AMTS OF WATER FOR AT LEAST 15 MINUTES.
GET MED ATTN. SKIN: REMOVE CONTAM CLOTHING AND WASH CONTACT AREA
WITH MILD SOAP AND WATER. IF IRRITATION DEVELOPS OR PERSISTS, GET
MEDICAL A TTENTION. INHALATION: REMOVE TO FRESH AIR. IF BREATHING
IS DIFFICULT, ADMINISTER OXYGEN. INGESTION: GET IMMEDIATE MEDICAL
ATTN. IF CONSCIOUS, GIVE LRG QTYS OF H*2O TO DILUTE, BUT DO NOT
INDUCE VOMIT.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>340F,>171C
Extinguishing Media:CARBON DIOXIDE, FOAM, DRY CHEMICAL OR WATER SPRAY.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:DECOMPOSITION AND COMBUSTION PRODUCTS MAY
BE TOXIC.
================== Accidental Release Measures ==================
Spill Release Procedures:AVOID ALL PERSONAL CONTACT. DIKE SPILL. ABSORB
WITH INERT MATERIAL AND COLLECT FOR DISPOSAL. FLUSH CONTAMINATED
AREA WITH WATER; PREVENT WASHINGS FROM ENTERING WATERWAYS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT EXCEED 110F/43C IN STORAGE
AREA.
Other Precautions:AVOID ALL PERSONAL CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR WITH ORGANIC
VAPOR CARTRIDGE IS REQUIRED.
Ventilation:MECH VENT & LOC EXHST ARE RECOMMENDED. MECH EXHST IS NOT
RECOMMENDED AS SOLE MEANS OF CONTROLLING EMPLOYEE EXPOSURE.
Other Protective Equipment:IN OPERATIONS WHERE CONTACT MAY OCCUR
COVERALLS, APRON AND IMPERVIOUS FOOT COVERING ARE RECOMMENDED.
SAFETY (SUPDAT)
Work Hygienic Practices:IMMEDIATELY REMOVE AND THOROUGHLY LAUNDER
CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
OTHER PROTECTIVE EQUIPMENT: SHOWER AND EYE BATH SHOULD BE AVAILABLE.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>200F,>93C
Vapor Pres:<0.01 @68F
Spec Gravity:1.02
Solubility in Water:MISCIBLE
Appearance and Odor:YELLOW LIQUID, AMINE ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:EXCESSIVE HEAT.
Hazardous Decomposition Products:CO*2, CO, ALDEHYDES AND NO*X.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE AND
LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ICRONIBSI 16 (AMS-4776) BRAZE ALLOYS
CAGE:UO704
CAGE:UO704
============= Composition/Information on Ingredients =============
Ingred Name:BORON
CAS:7440-42-8
RTECS #:ED7350000
= Wt:3.8
Ingred Name:CHROMIUM
CAS:7440-47-3
RTECS #:GB4200000
= Wt:16.5
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:IRON
CAS:7439-89-6
RTECS #:NO4565500
= Wt:4.
Ingred Name:NICKEL
CAS:7440-02-0
RTECS #:QR5950000
= Wt:71.7
OSHA PEL:1 MG/M3
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:SILICON
CAS:7440-21-3
RTECS #:VW0400000
= Wt:4.
OSHA PEL:15 MG/M3
ACGIH TLV:10 MG/M3
===================== Hazards Identification =====================
Health Hazards Acute and Chronic:THE ALLOYS IN SOLID FORM ARE GENERALLY
NOT CONSIDERED HAZARDOUS. HOWEVER, IF YOUR PROCESS INVOLVES
GRINDING, MELTING, WELDING, CUTTING, OR OTHER PROCESSES THAT CAUSE
A RELEASE OF DUST OR FUME, THEN HA ZARDOUS LEVELS OF DUST OR FUME
OF CONSTITUENTS OF THESE ALLOYS CAN CAUSE ACUTE TOXICITY. TARGET
ORGANS: EYE, SKIN AND RESPIRATORY SYSTEM.
Explanation of Carcinogenicity:SOME OF THE PRODUCT'S INGREDIENTS ARE
FOUND ON THE FEDERAL OSHA Z LIST, NTP, CAL/OSHA OR IARC. CHROMIUM,
COBALT-CHROMIUM ALLOYS, & NICKEL HAVE BEEN IDENTIFIED BY IARC &/OR
NTP AS POTENTIAL CANCER CAUS ING AGENTS.
Effects of Overexposure:USER GENERATED DUST & FUMES MAY ON CONTACT WITH
THE SKIN OR EYES PRODUCE MECHANICAL IRRITATION. CHRONIC EXPOSURES
COULD CAUSE DERMATITIS (SKIN) OR CONJUNCTIVITIS (EYES). EXCESSIVE
INHALATION OF USER G ENERATED FUMES FROM WELDING/BRAZING WITH THESE
PRODUCTS MAY, DEPENDING ON THE SPECIFIC FEATURES OF THE PROCESS
USED, POSE A LONG-TERM HEALTH HAZARD.
Medical Cond Aggravated by Exposure:CAUSING ALLERGIC REACTIONS IN
INDIVIDUALS SENSITIVE TO THE METAL(S) CONTAINED IN THESE PRODUCTS.
======================= First Aid Measures =======================
First Aid:INHALATION: IF LARGE AMOUNTS ARE INHALED, REMOVE TO FRESH
AIR. SUPPORT RESPIRATION AS NEEDED. SEEK MEDICAL ATTENTION FOR
TREATMENT, OBSERVATION AND SUPPORT AS NEEDED. SKIN CONTACT: WASH
AFFECTED AREA WITH MILD DETERGENT AND WATER. EYE CONTACT: FLUSH
EYES THOROUGHLY WITH WATER FOR AT LEAST 15 MINUTES. INGESTION: SEEK
MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Lower Limits:NA
Upper Limits:NA
Extinguishing Media:DRY CHEMICAL OR SAND. DO NOT USE WATER ON METAL
DUST FIRE.
Fire Fighting Procedures:SELF-CONTAINED BREATHING APPARATUS SHOULD BE
WORN WHEN FIGHTING METAL DUST FIRES.
Unusual Fire/Explosion Hazard:MAY OCCUR WITH CERTAIN METAL DUST FIRES.
THIS MATERIAL IS NONCOMBUSTIBLE UNDER NORMAL CIRCUMSTANCES.
HOWEVER, FINE POWDERS OR DUSTS (PRODUCED UPON GRINDING, CUTTING,
ETC.) OF CERTAIN METALS CAN PRODUC E FIRE & EXPLOSION HAZARDS,
UNDER CERTAIN CONDITIONS. DO NOT CREATE DUST CLOUDS.
================== Accidental Release Measures ==================
Spill Release Procedures:IN CASE OF A SPILL, CLEAR THE AFFECTED AREA,
PROTECT PEOPLE, & RESPOND WITH TRAINED PERSONNEL. FOR EXPOSURE TO
PURIFYING RESPIRATOR WITH A HEPA FILTER. SWEEP UP THE SPILLED SOLID
& PLACE ALL SPILL RESIDUE IN A DOUBLE PLASTIC BAG & SEAL.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID GETTING CHEMICAL ON YOU OR IN
YOU. WASH HANDS AFTER HANDLING CHEMICALS. DO NOT EAT OR DRINK WHILE
HANDLING CHEMICALS. ALL EMPLOYEES WHO HANDLE THIS MATERIAL SHOULD
BE TRAINED TO HANDLE IT SAFELY . (SEE BELOW)
Other Precautions:ALWAYS USE THIS PRODUCT IN AREAS WHERE ADEQUATE
VENTILATION IS PROVIDED. DECONTAMINATE EQUIPMENT USING SOAPY WATER
BEFORE MAINTENANCE BEGINS. XOLLECT ALL RINSATES AND DISPOSE OF
ACCORDING TO APPLICABL E FEDERAL, STATE, OR LOCAL PROCEDURES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE AN APPROPRIATE NIOSH APPROVED RESPIRATOR (IN
ACCORDANCE WITH 29 CFR 1910.134) IF AIRBORNE DUST/FUME
CONCENTRATIONS EXCEED THE APPLICABLE PEL OR TLV. ALL APPROPRIATE
REQUIREMENTS IN 29 CFR 1910.134 SHOULD BE MET. USE AIR-SUPPLIED
RESPIRATOR IN CONFINED SPACES.
Ventilation:PROVIDE SUFFICIENT GENERAL AND LOCAL EXHAUST VENTILATION TO
MAINTAIN AIR CONCENTRATIONS OF FUME OR DUST BELOW THE PEL AND TLV.
Other Protective Equipment:EYEWASH FOUNTAINS SHOULD BE READILY
AVAILABLE TO AREAS OF USE AND HANDLING. DEPENDING ON ENVEIRONMENT,
Work Hygienic Practices:DO NOT TAKE CLOTHING HOME.
Supplemental Safety and Health
SPILL OR LEAK: USE NORMAL CLEAN-UP PROCEDURES, WET USING SWEEPING
TAKING CARE TO AVOID CREATING DUST. VACUUM ONLY WITH HEPA FILTERED
EQUIPMENT. DO NOT USE COMPRESSED AIR FOR CLEAN-UP. SOME FINE METAL
POWDERS MAY IGNITE OR EXPLODE UNDER SPECIFIC CONDITIONS. TRAINED
PERSONNEL USING PRE=PLANNED PROCEDURES SHOULD RESPOND.
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:>450.C, 842.F
M.P/F.P Text:450-1800 C
Spec Gravity:6-9
Solubility in Water:INSOLUBLE
Appearance and Odor:METALLIC, NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE RESONABLY FORESEEABLE: COPPER IS EXPLOSIVELY INCOMPATIBLE WITH
SODIUM OZIDE. COPPER DUST MAY REACT WITH ACETYLENE GAS TO FORM
COPPER-ACETYLIDES, WHICH IS SENSITIVE TO SHOCK.
Stability Condition to Avoid:OPEN FLAME FOR SOME FINE POWDERS.
Hazardous Decomposition Products:METAL (OXIDE) FUME OR DUST.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
=================== Toxicological Information===================
Toxicological Information:AS SHIPPED, THESE ALLOYS HAVE NO KNOWN
(UNLESS INGESTED) TOXICOLOGICAL PROPERTIES OTHER THAN CAUSING
ALLERGIC REACTIONS IN INDIVIDUALS SENSITIVE TO THE METAL(S)
CONTAINED IN THESE PRODUCTS. USER GENER ATED DUST & FUMES MAY ON
CONTACT WITH THE SKIN OR EYES PRODUCE MECHANICAL IRRITATION.
CHRONIC EXPOSURES COULD CAUSE DERMATITIS (SKIN) OR CONJUNCTIVITIS
(EYES). EXCESSIVE INHALATION OF USER GENERATED F UMES FROM
WELDING/BRAZING WITH THESE PRODUCTS MAY, DEPENDING ON THE SPECIFIC
FEATURES OF THE PROCESS USED, POSE A LONG-TERM HEALTH HAZARD. THE
INTERNATIONAL AGENCY FOR RESEARCH ON CANCER (IARC) HAS CO NCLUDED
THAT WELDING FUMES ARE POSSIBL
===================== Ecological Information =====================
Ecological:ENVIRONMENTAL STABILITY: MOST OF THE METALS ELEMENTS ARE
NATURALLY PRESENT IN THE SOIL & WATER. INDIVIDUAL METAL'S TRANSPORT
IN THE ENVIRONMENT DEPENDS UPON THE EXACT COMPOUND, THE PH, THE
SOIL TYPE,& THE SALINITY. ALL WORK PRACTICES SHOULD BE AIMED AT
ELIMINATING ENVIRONMENTAL CONTAMINATION.
==================== Disposal Considerations ====================
Waste Disposal Methods:IT IS THE RESPONSIBILITY OF THE PRODUCT USER TO
DETERMINE AT THE TIME OF DISPOSAL WHETHER A MATERIAL CONTAIN THE
PRODUCT OR DERIVED FROM THE PRODUCT SHOULD BE CLASSIFIED AS
HAZARDOUS WASTE (40 CFR 261 .20). ALWAYS DISPOSE OF IN ACCORDANCE
WITH ALL APPLICABLE FEDERAL, STATE AND LOCAL REGULATIONS. WHER EVER
POSSIBLE TRY TO RECYCLE AND RECLAIM THE METAL
=================== MSDS Transport Information ===================
Transport Information:THIS ALLOYS ARE NOT CONSIDERED HAZARDOUS AS
DEFINED BY 49 CFR 172.101 BY THE US DEPARTMENT OF TRANSPORTATION AT
THE QUANTITY NORMALLY SHIPPED. FOR BULK SHIPMENT OF MORE THAN 1000
LBS SOME METALS MAY B E CONSIDERED HAZARDOUS.
===================== Regulatory Information =====================
SARA Title III Information:SARA 311/312: ACUTE-NO. CHRONIC-YES.
FIRE-NO. PRESSURE-NO. REACTIVITY-NO (PURE/SOLI). SARA 313: THIS
PRODUCT CONTAINS THE FOLLOWING CHEMICALS, WHICH ARE SUBJECT TO
REPORTING REQUIREMENTS OF SECTION 31 3 OF THE EMERGENCY PLANNING &
COMMUNITY RIGHTTO-KNOW ACT OF 1986. CONSUMER MUST REVIEW THEIR
SPECIFIC ALLOYS TO DETERMINE THE AMOUNT OF EACH ELEMENT USED:
NICKEL, COPPER, SILVER, COBALT, MANGANESE, CH ROMIUM, MOLYBDENUM
(TRIOXIDE ONLY), VANADIUM (FUME/DUST ONLY).
Federal Regulatory Information:OSHA-COMPLY WITH HAZARD COMMUNICATION
STANDARDS 29CFR1910.1200 & 1926.59 & RESPIRATORY PROTECTION
STANDARD 29CFR 1910.134 & 1926.103. SOME COMPONENTS OF THIS PRODUCT
ARE CONSIDERED TO BE HAZARDOUS AS DEFINED BY OSHA. TSCA-THESE ARE
MIXTURE OF VARIOUS METALS COMPONENTS. THE CAS NUMBERS OF ALL
INDIVIDUAL CHEMICALS ARE LISTED TSCA CHEMICAL INVENTORY.
CERCLA-CHROMIUM & COMPOUNDS, COPPER AND COMPOUNDS,NICKEL & ITS
COMPOUNDS, SILVER & ITS COMPOUNDS, VANADIUM (OXIDES & PENTAOXIDE),
ZINC & COMPOUNDS.
State Regulatory Information:PROPOSITION 65-THIS PRODUCT CONTAINS THE
FOLLOWING "CHEMICALS KNOWN TO THE STATE OF CALIFORNIA" TO CAUSE
CANCER AND/OR REPRODUCTIVE TOXICITY: COBALT AND COBALT COMPOUNDS,
CHROMIUM VI AND ITS COMPOUNDS , NICKEL AND NICKEL COMPOUNDS.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:INCO NICKEL POWDER TYPE 123
CAGE:74900
CAGE:74900
============= Composition/Information on Ingredients =============
Ingred Name:NICKEL (SARA III)
CAS:7440-02-0
RTECS #:QR5950000
Fraction by Wt: 99.1%
Other REC Limits:1 MG/CUM
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3; 9192
Ingred Name:NICKEL (II) OXIDE
CAS:1313-99-1
RTECS #:QR8400000
Fraction by Wt: 0.3%
Other REC Limits:1 MG/CUM
OSHA PEL:1 MG/CUM
ACGIH TLV:1 MG/CUM
Ingred Name:NICKEL CARBIDE
CAS:12167-08-7
Fraction by Wt: 0.5%
OSHA PEL:1 MG/CUM
ACGIH TLV:1 MG/CUM
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL RATS LD50 = >9000 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHALATION: IRRITATION. SKIN: REPEATED
CONTACT W/METALLIC NICKEL CAN CAUSE SENSITIVITY & ALLERGIC RASHES.
INGESTION: LOW TOXICITY.
Explanation of Carcinogenicity:NICKEL & COMPOUNDS, AS A GROUP BUT NOT
NECESSERILY AS INDIVIDUAL CHEMICALS, WERE CARCINOGENIC TO HUMANS.
Effects of Overexposure:INHALATION: IRRITATION. SKIN: REPEATED CONTACT
W/METALLIC NICKEL CAN CAUSE SENSITIVITY & ALLERGIC RASHES.
INGESTION: LOW TOXICITY.
Medical Cond Aggravated by Exposure:ALLERGIC SKIN RASHES OR PREVIOUSLY
SENSITIZED INDIVIDUALS.
======================= First Aid Measures =======================
First Aid:SKIN: CLEANSE WOUNDS THOROUGHLY TO REMOVE ANY PARTICLES.
INHALATION: IF EXPOSURE TO NICKEL CARBONYL IS SUSPECTED. OBTAIN
MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Unusual Fire/Explosion Hazard:METAL POWDERS HEAT TREATED IN REDUCING
ATMOSPHERES MAY BECOME PYROPHORIC. HYDROGEN GAS WHICH CAN FORM
EXPLOSIVE MIXTURES IN AIR.
================== Accidental Release Measures ==================
Spill Release Procedures:COLLECT SPILLS BY WET SWEEPING OR BY VACUUMING
W/THE VACUUM EXHAUST PASSING THROUGH A HIGH EFFICIENCY PARTICULATE
ARRESTING (HEPA) FILTER IF THE EXHAUST IS DISCHARGED INTO THE
WORKPLACE.
======================Handling and Storage ======================
Handling and Storage Precautions:NICKEL CONTAINING WASTE IS NORMALLY
COLLECTED TO RECOVER NICKEL VALUES. DON'T STORE NEAR ACIDS OR
REACTIVE SUBSTANCES. AVOID CONTACT W/SKIN.
Other Precautions:DON'T INHALE POWDER. KEEP CONTAINER CLOSED WHEN NOT
IN USE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR APPROPRIATE NIOSH APPROVED RESPIRATORS IF
COLLECTION & DISPOSAL OF SPILLS IS LIKELY TO CAUSE THE
CONCENTRATION OF AIRBORNE NICKEL TO EXCEED PEL.
Ventilation:NORMALLY REQUIRED WHEN HANDLING OR USING THIS PRODUCT TO
KEEP <PEL.
Work Hygienic Practices:WASH SKIN THOROUGHLY AFTER HANDLING. LAUNDER
Supplemental Safety and Health
EPIDEMIOLOGICAL STUDIES OF WORKERS EXPOSED TO NICKEL POWDER & TO DUST &
FUME GENERATED IN THE PRODUCTION NICKEL ALLOYS & OF A SIGNIFICANT
RESPIRATORY CANCER HAZARD.
================== Physical/Chemical Properties ==================
Solubility in Water:INSOLUBLE
Appearance and Odor:GRAY, ODORLESS POWDER W/AN AVERAGE PARTICLE SIZE OF
3 TO 7 MICRONS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS OR REACTIVE SUBSTANCES.
Hazardous Decomposition Products:CO, NICKEL CARBONYL, TOXIC GAS,
HYDROGEN GAS, AMMONIUM NITRATE, PERCHLORATES, PHOSPHORUS, SELENIUM
& SULPHUR, ETC.
==================== Disposal Considerations ====================
Waste Disposal Methods:SHOULD WASTE DISPOSAL BE DEEMED NECESSARY FOLLOW
EPA & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:A-29 CORROSION REMOVER
CAGE:52879
CAGE:52879
============= Composition/Information on Ingredients =============
Ingred Name:DEIONIZED WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 40.7%
Ingred Name:ISOPROPYL ALCOHOL (SARA III)
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 52.6%
OSHA PEL:400 PPM/500 STEL
ACGIH TLV:400 PPM/500STEL;9192
Ingred Name:VIRCINE ACID (CHELATES)
Fraction by Wt: 16.7%
===================== Hazards Identification =====================
Effects of Overexposure:MAY CAUSE ACID BURNS TO SKIN & EYES.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/PLENTY OF H*2O FOR @ LEAST 15 MIN. SKIN:REMOVE
CLOTHING & FLUSH SKIN WITH H*2O. INHAL: REMOVE TO FRESH AIR.
===================== Fire Fighting Measures =====================
Flash Point:NONE FLAMMABLE
================== Accidental Release Measures ==================
Spill Release Procedures:ADD SOLID ABSORBENT,SHOVEL/SCOOP INTO
DISPOSABLE CLOSED CONTAINERS.WASH & HOSE DOWN AREA.
======================Handling and Storage ======================
Handling and Storage Precautions:USE ACID RESISTANT MATERIALS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED SELF-CONTAINED REPIRATORY
EQUIPMENT.
Supplemental Safety and Health
ITEM COMPOSITION IS IN PERCENT BY VOLUME. BOILING POINT,VAPOR PRESS &
VAPOR DENSITY VALUES ARE FOR ISOPROPYL ALCOHOL
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:180F,(82C)
Vapor Pres:33
Vapor Density:2.07
Spec Gravity:1.02
Evaporation Rate & Reference:2.3(BUTYL ACETATE)
Solubility in Water:COMPLETE
Appearance and Odor:LIGHT BLUE/GREEN COLOR;MILD ODOR.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALKALINE MATERIALS
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH LOCAL,STATE & FEDERAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:1008151,LIQUITEX ACRYLIC ARTIST COLOR 8 OZ(
CAGE:BINNE
CAGE:BINNE
CAGE:85419
============= Composition/Information on Ingredients =============
Ingred Name:2-NAPTHOL, 1-((4-(O-TOLYAZO)-O-TOLYL)AZO)-; (LACQUER
RED/CADMIUM RED, MEDIUM, HUE)
CAS:85-83-6
RTECS #:QL5775000
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: INERT, NUISANCE PARTICULATE DUST.
SKIN: NON-TOXIC. INHAL: INERT, NUISANCE PARTICULATE DUST. INGEST:
PRODUCT MAY BE IRRITATING TO GI TRACT IF INGEST. PRODS HAVE BEEN
CERTIFIED AS NON-TOXIC BY ART & CRAFT MATLS INSTITUTE & CONFORM TO
ASTM D 4236 STANDARD PRACTICE FOR LABELING ART MATLS FOR CHRONIC
ADVERSE HLTH HAZ.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:NO SPECIFIC HAZARD IS KNOWN.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN, EYE AND
RESPIRATORY DISORDERS, IMPAIRED FUNCTIONS FROM PRE-EXISTING
DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:EYE:IMMED FLUSH WITH WATER FOR AT LEAST 15 MINUTES. SEEK
MEDICAL ATTN IF ANY SYMPTOMS PERSIST. SKIN:WIPE EXCESS FROM SKIN
AND FLUSH WITH WATER USING SOAP IF AVAILABLE. SEEK MEDICAL ATTN IF
IRRITATIONOCCURS. INHAL:REMOVE VICTIM TO FRESH AIR AND TREAT
SYMPTOMATICALLY. INGEST:CALL MD, HOSPITAL OR POISON CONTROL CENTER
IF PRODUCT IS INGESTED.
===================== Fire Fighting Measures =====================
Flash Point:>212F,>100C
Extinguishing Media:USE WATER FOG, FOAM, DRY CHEMICAL OR CO2.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:PRODUCT AS SUPPLIED WILL SPLATTER AND
BOIL ABOVE 212F. PRODUCT WHEN DRY MAY DECOMPOSE AND IGNITE ABOVE
400F.
================== Accidental Release Measures ==================
Spill Release Procedures:SOAK UP RESIDUE W/AN ABSORB SUCH AS CLAY,
SAND/OTHER SUITABLE MATL; PLACE IN NON-LEAK CNTNRS FOR PROPER DISP.
FLUSH AREA W/WATER TO REMOVE TRACE RESIDUE;DISPOSE OF FLUSH SOLN AS
ABOVE.SM SPILLS-TAKE U P W/AN ABSORB MATL & PLACE IN NON-LEAK (SUPP
DATA)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT INHALE SPRAY FROM
AIRBRUSH/DUSTS FROM SANDING OPERATION.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE GOOD VENT-FOR DUST/MISTS,USE NIOSH/MSHA
CERTIFIED MASK. FOR AIR BRUSH: NIOSH/MSHA CERTIFIED RESP. DO NOT
INHALE SPRAY FROM AIR BRUSH. FOR SANDING DRIED PAINT: USE
NIOSH/MSHA CERTIFIED RESP. DO NOT INHALE FROM SANDING OPERATION.
Ventilation:USE VENT AS REQ TO CONTROL VAP CONC. USE WINDOW EXHST FAN
TO REMOVE VAPS & ASSURE ADEQ CROSS VENTILATION.
Other Protective Equipment:EYEWASH FOUNTAINS & SAFETY SHOWERS SHOULD BE
AVAILABLE FOR USE IN AN EMERGENCY.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
MFR PART NO: JAR LACQUER RED/CAD RED MEDIUM HUE. SPEC GRAV: 1.08-1.44
(H2O=1). % VOLAT: 50+/-10%. SPILL PROC:CNTNRS; SEAL TIGHTLY FOR
PROPER DISPOSAL.
================== Physical/Chemical Properties ==================
HCC:N1
Vapor Density:>1
Spec Gravity:SUPP DATA
Evaporation Rate & Reference:<1 (ETHER = 1)
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:SUPDAT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:CO2, CO AND UNDENTIFIED (UNKNOWN)
ORGANIC COMPOUNDS MAY BE FORMED DURING COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:REFER TO LATEST EPA OR STATE REGULATIONS
REGARDING PROPER DISPOSAL. DISPOSAL MUST BE IN ACCORDANCE WITH
FEDERAL, STATE AND LOCAL REGULATIONS .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:6117
CAGE:KO567
CAGE:82219
CAGE:KO567
============= Composition/Information on Ingredients =============
Ingred Name:COBALT (SARA III)
CAS:7440-48-4
RTECS #:GF8750000
OSHA PEL:0.1 MG/M3;AS CO
ACGIH TLV:0.05 MG/M3;DUST 9293
================== Accidental Release Measures ==================
============= Exposure Controls/Personal Protection =============
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:A2
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:IMX HBSAG 2.0 ALKALINE PHOSPHATASE CONJUGATE, 8C88H
Resp. Party Other MSDS Num.:O
CAGE:33110
CAGE:33110
============= Composition/Information on Ingredients =============
Ingred Name:TRIS(HYDROXYMETHYL)AMINOMETHANE; (TRIS HYDROXYMETHYL
AMINOMETHANE)
CAS:77-86-1
RTECS #:TY2900000
= Wt:1.2
Ingred Name:SODIUM AZIDE
CAS:26628-22-8
RTECS #:VY8050000
= Wt:.1
ACGIH STEL:C0.29 MG/M3
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
= Wt:94.8
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT): 590-1780 MG/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: NO IRRITANT EFFECT. EYE: NO
IRRITANT EFFECT. SENSITIZATION: NO SENSITIZING EFFECTS KNOWN.
TARGET ORGANS/SYSTEM: KIDNEYS. SPECIAL HAZARDS: NONE.
Explanation of Carcinogenicity:PRODUCT DOES NOT CONTAIN CARCINOGENS
LISTED BY IARC, NTP, OSHA OR ACGIH.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:PRE-EXISTING RENAL AILMENTS.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE FROM SOURCE OF EXPOSURE. IF SIGNS OF TOX OCCUR,
SEEK MED ATTN. PROVIDE SYMPTOMATIC/SUPPORTIVE CARE AS NEEDED. SKIN:
REMOVE FROM SOURCE OF EXPOSURE. FLUSH W/COPIOUS AMTS OF H*2O. IF
IRRIT PERSISTS/SIGNS OF TOX OCCURS, SEEK MED ATTN. PROVIDE
SYMPTOMATIC/SUPPORTIVE CARE AS NECESSARY. EYE: REMOVE FROM SOURCE
OF EXPOS. FLUSH W/COPIOUS AMTS OF H*2O FOR AT LEAST 15 MIN. IF
IRRIT PERSISTS/SI GNS OF TOX OCCURS, SEEK MED ATTN. PROVIDE
SYMPTOMATIC/SUPPORTIVE CARE AS NECESSARY. INGEST: REMOVE FROM
SOURCE OF EXPOSURE. IF SIGNS OF TOX OCCURS, SEEK MED ATTN.
===================== Fire Fighting Measures =====================
Extinguishing Media:CO*2, EXTINGUISHING POWDER OR WATER SPRAY. FIGHT
LARGER FIRES WITH WATER SPRAY OR ALCOHOL RESISTANT FOAM.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . RESPIRATORY PROTECTION NOT NORMALLY REQUIRED UNLESS
EXPOSURE LIMITS FOR COMPONENTS ARE EXCEEDED.
Unusual Fire/Explosion Hazard:PRODUCT DOES NOT PRESENT AN EXPLOSION
HAZARDS. PRODUCT IS NOT SELF IGNITING.
================== Accidental Release Measures ==================
Spill Release Procedures:SAFE WORK PRACTICES: NIOSH APPRVD RESP PROT
SHOULD BE WORN IF EXPOS LIMITS CAN BE EXCEEDED. MEASURES FOR
ENVIRONMENTAL PROTECTION: PREVENT LIQ & VAP FROM ENTERING INTO
SEWAGE SYSTEM, WORKPITS & CELLAR S. CONTAIN SPILL W/APPROP ABSORB
MATL. MEASURES FOR CLEANING/COLLECTING: ABSORB W/LIQUID-BUILDING
MATL (SAND, DIATOMITE, ACID BINDERS, UNIVERSAL (SUPDAT)
======================Handling and Storage ======================
Handling and Storage Precautions:INFO FOR SAFE HANDLING: NO SPECIAL
PRECAUTIONS ARE NECESSARY IF USED CORRECTLY. INFO ABOUT PROT
AGAINST EXPLOSIONS & FIRES: NO SPECIAL MEASURES REQUIRED. STORAGE
REQUIREMENTS TO BE MET BY STOREROOMS & RECEPTACLES: NO SPECIAL
REQUIREMENTS.
Other Precautions:INFO ABOUT STORAGE IN ONE COMMON STORAGE FACILITY: DO
NOT STORE TOGETHER W/ACIDS. FURTHER INFORMATION ABOUT STORAGE
CONDITIONS: PROTECT FROM HEAT & DIRECT SUNLIGHT: STORAGE CLASS: NOT
APPLICABLE. CLAS S ACCORDING TO REGULATION ON FLAMMABLE LIQUIDS:
NOT APPLICABLE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:THE APPROPRIATE NIOSH APPROVED RESPIRATORY
PROTECTION SHOULD BE USED IF AIRBORNE CHEMICAL CONCENTRATION
EXCEEDS THE EXPOSURE LIMITS (IF ANY) LISTED IN SECTION 8.
Ventilation:NOT NECESSARY IF ROOM IS WELL-VENTILATED.
Other Protective Equipment:EYEWASH & DELUGE SHOWER MTG ANSI DESIGN
CRITERIA . NOT NEEDED FOR SMALL QUANTITY USAGE. THE NEED FOR THE
APPROPRIATE BODY PROTECTION SHOULD BE DETERMINED ON A CASE BY CASE
BASIS.
Work Hygienic Practices:KEEP AWAY FROM FOODSTUFFS, BEVERAGES AND FEED.
WASH HANDS BEFORE BREAKS AND AT THE END OF WORK.
Supplemental Safety and Health
SPILL PROC: BINDERS, SAWDUST). ADDITIONAL INFORMATION: NO DANGEROUS
SUBSTANCES ARE RELEASED.
================== Physical/Chemical Properties ==================
Boiling Pt:=100.C, 212.F
Melt/Freeze Pt:M.P/F.P Text:NOT DETERMINED
Vapor Pres:23.0 @ 20C
Spec Gravity:1.028 @ 20C
pH:7.5 @ 20C
Solubility in Water:FULLY MISCIBLE
Appearance and Odor:COLORLESS LIQUID; ODORLESS.
================= Stability and Reactivity Data =================
REACTIONS WITH HEAVY METALS MAY FORM EXPLOSIVE SUBSTANCES. CONTACT WITH
ACIDS MAY RELEASE TOXIC GAS (I.E. HYDROGEN AZIDE HN*3).
Hazardous Decomposition Products:NO DECOMPOSITION IF USED ACCORDING TO
SPECIFICATIONS.
=================== Toxicological Information===================
Toxicological Information:ACUTE TOXICITY: LD/LC50 VALUES FOR HAZARDOUS
INGREDIENTS PER OSHA CRITERIA: COMPONENTS (100% PURE SUBSTANCE/S)
77-86-1 TRIS HYDROXYMETHYL AMINOMETHANE. ORAL: LD50: 590-1780 MG/KG
(RAT). LDL0 = 1000 MG /KG IN RABBITS.
===================== Ecological Information =====================
Ecological:GENERAL NOTES: NOT KNOWN TO BE A WATER POLLUTANT.
==================== Disposal Considerations ====================
Waste Disposal Methods:PRODUCT & UNCLEANED PACKAGINGS: RECOMMENDATION:
DISPOSE IN ACCORDANCE WITH FEDERAL, STATE AND LOCAL REGULATIONS.
RECOMMENDED CLEANSING AGENT: WATER, IF NECESSARY WITH CLEANSING
AGENTS.
=================== MSDS Transport Information ===================
Transport Information:DOT REGULATIONS: HAZARD CLASS: REMARKS: NOT
REGULATED FOR TRANSPORTATION. LAND TRANSPORT ADR/RID (CROSS-BORDER)
ADR/RID CLASS: REMARKS: NOT REGULATED FOR TRANSPORTATION. IMDG
CLASS: MARINE POLLUTANT: NO. REMARKS: NOT REGULATED FOR
TRANSPORTATION. AIR TRANSPORT ICAO-TI AND IATA-DGR: ICAO/IATA
CLASS: REMARKS: NOT REGULATED FOR TRANSPORTATION.
===================== Regulatory Information =====================
SARA Title III Information:NATIONAL AND INTERNATIONAL REGULATIONS. SARA
(SUPERFUND AMENDMENTS & REAUTHORIZATION ACT OF 1986 - USA): SECTION
302/304 (40CRF355.30/40CFR355.40): 26628-22-8 SODIUM AZIDE. SECTION
313 (40CFR372.65):26628-22-8 SODIUM AZIDE.
Federal Regulatory Information:MARKINGS ACCORDING TO EUROPEAN
GUIDELINES: THE PRODUCT HAS BEEN CLASSIFIED & LABELLED
I/A/W/APPLICABLE EUROPEAN COMMUNITY (EC) DIRECTIVES. CODE LETTER &
HAZARD DESIGNATION OF PRODUCT: XN. HAZARD-DETER MINING SUBSTANCE/S
OF LABELLING: SODIUM AZIDE. RISK PHRASES: 22 HARMFUL IF INGESTED.
32 CONTACT W/ACIDS LIBERATES VERY TOXIC GAS. SAFETY PHRASES: 2 KEEP
OUT OF REACH OF CHILDREN. 13 KEEP AWAY FROM FOO D, DRINK, & ANIMAL
FEEDINGSTUFFS. 36 WEAR SUITABLE PROTECTIVE CLOTHING. 46 IF
INGESTED. SEEK MEDICAL ADVICE IMMEDIATELY & SHOW THIS
CONTAINER/LABEL. CLASSIFICATION/WARNING ACCORDING TO WORKSAFE
AUSTRALIA: HAZARDOUS.
State Regulatory Information:CALIFORNIA PROPOSITION 65 (USA): CHEMICALS
KNOWN TO CAUSE CANCER: THE PRODUCT DOES NOT CONTAIN LISTED
SUBSTANCES.
======================= Other Information =======================
| 1 | gloves_mandatory |
=======================================================
NIIN: 01-290-1938
Product ID: ENAMEL NONFLAMING CHLORINATED ALKYD RESIN PEARL GRAY FORM130
Cage: DO436
=======================================================
Contractor Summary
=======================================================
Cage: DO436
Cage: 33291
=======================================================
Item Description Information
=======================================================
Item Manager: GSA
Item Name: ENAMEL
Unit of Issue: GL
UI Container Qty: 0
=======================================================
Ingredients
=======================================================
Cas: 13463-67-7
RTECS #: XR2275000
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: 15 MG/M3 AS DUST
------------------------------
Cas: 7727-43-7
RTECS #: CR0600000
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: 5 MG/M3 AS DUST
------------------------------
Cas: 14742-47-8
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: 125 PPM 8 HR
-----------------------------
RTECS #: 9999999VO
% Wt: NA
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT RELEVANT
ACGIH TLV: NOT RELEVANT
-----------------------------
Cas: 1333-86-4
RTECS #: FF5800000
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: 3.5 MG/M3 AS DUST
------------------------------
Cas: 64742-47-8
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: 10 MG/M3 AS DUST
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: INHALING HIGH CONCENTRATIONS MAY CAUSE TEMPORARY
DIZZINESS/HEADACHES/NAUSEA RANGING FROM CONVULSIONS/LOSS
CONSCIOUSNESS.SYMPTOMS GENERALLY DISAPPEAR WHEN EXPOSURE CEASES.
Signs And Symptions Of Overexposure: TEMPORARY DIZZINESS, HEADACHE, NAUSEA.
RANGING FROM CONVULSIONS, LOSS OF CONSCIOUSNESS. SYMPTOMS GENERALLY DISAPPEAR
WHEN EXPOSURE CEASES.
First Aid: INHALATION: MOVE TO FRESH AIR IMMEDIATELY. CALL DR IF BREATHING
IRREGULAR/STOPPED START ARTIF RESP. GIVE OXYGEN. WASH EYES W/WATER. REMOVE
CONTAM CLOTHES. WASH SKIN THOROUGHLY.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: REMOVE ALL IGNITION SOURCES & PROVIDE
VENTILATION. LARGE SPILLS MAY BE SCOOPED UP W/NONSPARKING TOOLS. AVOID
BREATHING VAPORS. GIVE RESP PROTECTION IF REQ. SMALL AMTS MAY BE PICKED UP
W/DRY ABSORBENT.
Waste Disposal Methods: PLACE IN CLOSED CONTAINERS. RAGS/ABSORBENTS SHOULD BE
IMMERSED IN WATER. USE SANITARY LANDFILLS ACCORDING TO LOCAL, STATE, FEDERAL
REGS. RUN-OFF TO WATERWAYS CREATES FIRE HAZARD. NOTIFY FIRE/HEALTH AG ENCIES.
Handling And Storage Precautions: AVOID CHRONIC BREATHING OF VAPORS/SKIN
CONTACT. RESIN ACCUMULATION (SPRAY/BOOTH CLEANINGS) MAY SPONTANEOUSLY IGNITE.
IMMERSE ACCUMULATIONS IN WATER.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: TCC
Flash Point Text: 104F,40C
Lower Limits: 1.0
Upper Limits: 6.0
Extinguishing Media: FOAM, CO2, DRY CHEMICAL, FOG.
Fire Fighting Procedures: USED AIR-SUPPLIED RESCUE EQUIPMENT FOR ENCLOSED
AREAS. COOL CONTAINERS W/WATER.
Unusual Fire/Explosion Hazard: KEEP AWAY FROM HEAT, SPARKS, OPEN FLAME.
=======================================================
Control Measures
=======================================================
Respiratory Protection: HYDROCARBONS OR ORGANIC VAPOR CANISTER, SUPPLIED W/AIR
MASK.
Ventilation: LOCAL EXHAUST. USE ADEQUATE VENTILATION.
Work Hygienic Practices: KEEP OFF OF SKIN, HANDS & FACE.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: 316 TO 380F
Vapor Pres: 22.0
Vapor Density: >AIR
Spec Gravity: 1.734
Evaporation Rate & Reference: 0.2 (BUAC=1)
Solubility in Water: SLIGHT
Appearance and Odor: GRAY, MINERAL SPIRITS ODOR
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: HIGH TEMPERATURES OR HEAT.
Materials To Avoid: OXYGEN OR STRONG OXIDENTS WILL DISOLVE OR SOFTEN SOME
PLASTICS OR RUBBER.
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
Transportation Information
=======================================================
Trans ID NO: 122482
Product ID: ENAMEL NONFLAMING CHLORINATED ALKYD RESIN PEARL GRAY FORM130
Review Date: 10/15/1996
Multiple KIT Number: 0
Review IND: Y
Unit Of Issue: GL
Container QTY: 0
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: LFE
DOT Proper Shipping Name: PAINT
DOT PSN Modifier: INCLUDING PAINT, LACQUER, ENAMEL, STAIN, SHELLAC SOLUTIONS,
VARNISH, POLISH, LIQUID FILLER, AND LIQUID LACQUER BASE
Hazard Class: 3
UN ID Num: UN1263
DOT Packaging Group: III
Label: FLAMMABLE LIQUID
Special Provision: B1,B52,T7,T30
Packaging Exception: 150
Non Bulk Pack: 173
Bulk Pack: 242
Max Qty Pass: 60 L
Max Qty Cargo: 220 L
Vessel Stow Req: E,B,A
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: LCT
IMO Proper Shipping Name: PAINT OR PAINT RELATED MATERIAL
IMO PSN Modifier: (INCLUDING PAINT, LACQUER, ENAMEL, STAIN, SHELLAC SOLUTIONS,
VARNISH, POLISH, LIQUID FILLER AND LIQUID LACQUER BASE) OR (INCLUDING PAINT
THINNING OR REDUCING COMPOUND) o
IMDG Page Number: 3372
UN Number: 1263
UN Hazard Class: 3.3
IMO Packaging Group: III
Subsidiary Risk Label: -
EMS Number: 3-05
MED First Aid Guide NUM: 310
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: SXH
IATA UN ID Num: 1263
IATA Proper Shipping Name: PAINT
IATA PSN Modifier: (INCLUDING PAINT, LACQUER, ENAMEL, STAIN, SHELLAC, VARNISH,
POLISH, LIQUID FILLER AND LIQUID LACQUER BASE)
IATA UN Class: 3
IATA Label: FLAMMABLE LIQUID
UN Packing Group: III
Packing Note Passenger: 309
Max Quant Pass: 60L
Max Quant Cargo: 220L
Packaging Note Cargo: 310
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: SXH
AFI Proper Shipping Name: PAINT OR PAINT RELATED MATERIAL
AFI PSN Modifier: (INCLUDING PAINT, LACQUER, ENAMEL, STAIN, SHELLAC SOLUTIONS,
VARNISH, POLISH, LIQUID FILLER AND LIQUID LACQUER BASE) OR (INCLUDIN PAINT
THINNING OR REDUCING COMPOUNDS)
AFI Hazard Class: 3
AFI UN ID NUM: UN1263
AFI Packing Group: III
Special Provisions: P5
Back Pack Reference: A7.3
=======================================================
HAZCOM Label
=======================================================
Product ID: ENAMEL NONFLAMING CHLORINATED ALKYD RESIN PEARL GRAY FORM130
Cage: DO436
Assigned IND: Y
Company Name: LYLE VAN PATTEN CO, INC
Street: 321 WEST 135TH STREET
Zipcode: 90061
Label Required IND: Y
Date Of Label Review: 10/12/1999
Status Code: A
Origination Code: G
Hazard And Precautions: INHALING HIGH CONCENTRATIONS MAY CAUSE TEMPORARY
DIZZINESS/HEADACHES/NAUSEA RANGING FROM CONVULSIONS/LOSS
CONSCIOUSNESS.SYMPTOMS GENERALLY DISAPPEAR WHEN EXPOSURE CEASES.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:HALON 1211
Preparer's Name:D. EMERICH OR D. ELLISON
CAGE:54905
CAGE:54905
============= Composition/Information on Ingredients =============
Ingred Name:HALON 1211
CAS:353-59-3
RTECS #:PA5270000
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE/SKIN: CAN PRODUCE CHILLING
SENSATIONS & DISCOMFORT, REDNESS, ITCHING, BURNING. INHALATION:
EXPOSURES FOR MORE THAN A FEW MINUTES >4% CONCENTRATION CAN PRODUCE
DIZZINESS, IMPAIRED COORDINATION & CA RDIAC EFFECTS. INGESTION:
THIS MATERIALIS A GAS AT ROOM TEMPERATURE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYE/SKIN: CAN PRODUCE CHILLING SENSATIONS &
DISCOMFORT, REDNESS, ITCHING, BURNING. INHALATION: EXPOSURES FOR
MORE THAN A FEW MINUTES >4% CONCENTRATION CAN PRODUCE DIZZINESS,
IMPAIRED COORDINATION & CA RDIAC EFFECTS. INGESTION: THIS
MATERIALIS A GAS AT ROOM TEMPERATURE.
Medical Cond Aggravated by Exposure:IN SUSCEPTIBLE INDIVIDUALS, CARIDAC
SENSITIZATION TO CIRCULATING EPINEPHRINE COMPOUNDS CAN RESULT IN
POTENTIALLY FATAL HEART ARRHYTHMIAS.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR 15 MINUTES. IF REDNESS, ITCHING OR
BURNING SENSATION DEVELOPS, GET EXAMINED & TREATED BY MEDICAL
PERSONNEL. SKIN: WASH W/SOAP & WATER. IF REDNESS, ITCHING OR
BURNING SENSATION DEVELOPS, SEEK MED ATT. INHALATION: MOVE TO
FRESH AIR. IF COUGH OR OTHER RESPIRATORY SYMPTOMS DEVELOP, CONSULT
MEDICAL PERSONNEL. INGESTION: GIVE 1 OR 2 GLASSES OF WARM WATER &
SEEK MED ATT.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:NONE. THIS MATERIAL IS AN EXTINGUISHING AGENT.
Fire Fighting Procedures:SCBA W/FULL FACEPIECE & PROTECTIVE CLOTHING
WHEN RE-ENTERING UNVENTILATED FIRE AREAS.
Unusual Fire/Explosion Hazard:WHEN HALON 1211 IS DISCHARGED ONTO FIRE,
IT DECOMPOSES >900F, RELEASING BROMIDE IONS. THESE BY-PRODUCTS,
ALTHOUGH HARMFUL IF INHALED ARE EASILY DETECTED.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE SPILL AREA & RECOVER ANY LIQUID.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL AREA W/GOOD
VENTILATION. KEEP VAPORS AWAY FROM HIGH TEMPERATURE SURFACES TO
AVOID TOXIC & CORROSIVE DECOMPOSITION PRODUCTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE MSHA/NIOSH APPROVED RESPIRATOR FOR ORGANIC
VAPORS.
Ventilation:LOCAL EXHAUST/MECHANICAL: RECOMMENDED.
Other Protective Equipment:EYE WASH STATION & SAFETY SHOWER IN WORK
AREA WHEN WORKING W/LIQUIFIED PRODUCT.
Work Hygienic Practices:USE GOOD PERSONAL HYGIENE & GOOD HOUSEKEEPING
PRACTICES.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:26F
Vapor Pres:778
Vapor Density:5.7
Spec Gravity:1.83
Evaporation Rate & Reference:HIGH
Solubility in Water:NONE
Appearance and Odor:COLORLESS GAS & LIQUID WITH VERY FAINT, SWEET ODOR.
Percent Volatiles by Volume:100%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACTIVE METALS SUCH AS POWDERED ALUMINA/MAGNESIUM & FIRES OF METAL
HYDRIDES.
Stability Condition to Avoid:DECOMPOSES UNDER FIRE CONDITIONS.
Hazardous Decomposition Products:DECOMPOSES >900F TO GIVE FREE
HALOGENS, HALOGEN ACID/SMALL AMOUNTS OF CARBONYL HALIDES.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:POLY-GAMMA-METHYL L-GLUTAMATE MOL WT 10000-50000, P1388
CAGE:21076
CAGE:21076
============= Composition/Information on Ingredients =============
Ingred Name:POLY-GAMMA-METHYL L-GLUTAMATE
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: MAY BE HARMFUL BY INHALATION,
INGESTION, OR SKIN ABSORPTION. MAY CAUSE IRRITATION.
Effects of Overexposure:SEE HEALTH HAZARDS.
======================= First Aid Measures =======================
First Aid:INGESTION: WASH OUT MOUTH WITH WATER PROVIDED PERSON IS
CONSCIOUS. CALL A PHYSICIAN. SKIN: FLUSH WITH COPIOUS AMOUNTS OF
WATER FOR AT LEAST 15 MINUTES. REMOVE CONTAMINATED CLOTHING AND
SHOES. CALL A P HYSICIAN. INHALATION: REMOVE TO FRESH AIR. IF
BREATHING BECOMES DIFFICULT, CALL A PHYSICIAN. EYES: FLUSH WITH
COPIOUS AMOUNTS OF WATER FOR AT LEAST 15 MINUTES. ASSURE ADEQUATE
FLUSHING BY SEPARATING T HE EYELIDS WITH FINGERS. CALL A PHYSICIAN.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL POWDER
OR APPROPRIATE FOAM.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
================== Accidental Release Measures ==================
HOLD FOR WASTE DISPOSAL. AVOID RAISING DUST. VENTILATE AREA AND
WASH SPILL SITE AFTER MATER IAL PICKUP IS COMPLETE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR APPROPRIATE NIOSH APPROVED RESPIRATOR.
Ventilation:MECHANICAL EXHAUST REQUIRED.
Other Protective Equipment:EYE WASH AND DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA . OTHER PROTECTIVE CLOTHING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Appearance and Odor:SOLID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:NATURE OF DECOMPOSITION PRODUCTS NOT
KNOWN.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
=================== Toxicological Information===================
Toxicological Information:THE TOXICOLOGICAL PROPERTIES HAVE NOT BEEN
THOROUGHLY INVESTIGATED.
===================== Ecological Information =====================
Ecological:DATA NOT YET AVAILABLE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISSOLVE OR MIX THE MATERIAL WITH A COMBUSTIBLE
SOLVENT AND BURN IN A CHEMICAL INCINERATOR EQUIPPED WITH AN
AFTERBURNER AND SCRUBBER. OBSERVE ALL FEDERAL, STATE AND LOCAL
ENVIRONMENTAL REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:CONTACT SIGMA CHEMICAL COMPANY FOR TRANSPORTATION
INFORMATION.
===================== Regulatory Information =====================
Federal Regulatory Information:EUROPEAN INFORMATION: CAUTION: SUBSTANCE
NOT YET FULLY TESTED.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:2252 ENZOL ENZYMATIC DETERGENT
CAGE:04ES7
CAGE:04ES7
============= Composition/Information on Ingredients =============
Ingred Name:SUBTILISIN
CAS:9014-01-1
RTECS #:CO9550000
Minumum % Wt:1.
Maxumum % Wt:10.
ACGIH STEL:C0.00006 MG/M3
Ingred Name:DODECYLPHENOLETHOXYLATE
CAS:9014-92-0
RTECS #:TR1581300
Minumum % Wt:1.
Maxumum % Wt:10.
Ingred Name:SODIUM XYLENE SULFONATE
CAS:1300-72-7
RTECS #:ZE5100000
Minumum % Wt:1.
Maxumum % Wt:10.
Ingred Name:PROPYLENE GLYCOL
CAS:57-55-6
RTECS #:TY2000000
Minumum % Wt:20.
Maxumum % Wt:30.
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Minumum % Wt:40.
Maxumum % Wt:77.
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: CAUSES IRRITATION. SKIN:
PROLONGED/REPEATED CONTACT MAY CAUSE IRRITATION/SENSITIZATION.
INGESTION: MAY BE HARMFUL IF SWALLOWED.
Effects of Overexposure:IRRITATION
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH W/WATER & CONTINUE WASHING FOR 15
MINS. SKIN: FLUSH W/WATER. INGESTION: DRINK LARGE QUANTITIES OF
WATER/MILK. DON'T INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:NONE
Extinguishing Media:CO2/DRY CHEMICAL FOR SMALL FIRES. FOR LARGE: FOAM
(ALCOHOL/POLYMER/ORDINARY)/WATER FOG.
Fire Fighting Procedures:USE SELF CONTAINED BREATHING APPARATUS &
PROTECTIVE CLOTHING.
================== Accidental Release Measures ==================
Spill Release Procedures:WIPE W/SPONGE/MOP DOWN AREA W/WATER. FLUSH
W/LARGE QUANTITIES OF WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AT CONTROLLED ROOM TEMPERATURE
59-86F.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED
Ventilation:USE W/STANDARD ROOM VENTILATION, AIR CONDITIONING/NATURAL
DRAFTS
Work Hygienic Practices:AVOID CONTAMINATION OF FOOD.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:>100.C, 212.F
Spec Gravity:1.03
pH:6-8
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, VIOLET LIQUID W/MINT ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Stability Condition to Avoid:TEMPERATURES >104F & EVAPORATION OF WATER
Hazardous Decomposition Products:CO, CO2, SULFUR OXIDES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCARD SOLUTION W/LARGE QUANTITIES OF WATER.
THOROUGHLY RINSE CONTAINER BEFORE DISPOSING IN A WASTE
RECEPTACLE/RECYCLING. DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:NOT REGULATED
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:UNIVOLT INSULATING OILS ANSI/ASTM D3487 TYPE I OR II
CAGE:EO384
CAGE:29700
CAGE:EO384
CAGE:25050
============= Composition/Information on Ingredients =============
Ingred Name:NO INGREDIENT FOR THIS FORMULATION_INGREDIENT
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RATS) > 5 G/KG
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PROLONGED OR REPEATED SKIN CONTACT MAY
CAUSE SKIN IRRITATION. PROLONGED OR REPEATED CONTACT TENDS TO
REMOVE SKIN OILS, POSSIBLY LEADING TO IRRITATION AND DERMATITIS.
EYE CONTACT MAY CAUSE IRRITATION. ASPIRATION HAZARD.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:SKIN IRRITATION, DERMATITIS, EYE IRRITATION,
CHEMICAL PNEUMONIA.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR 15 MINUTES WHILE HOLDING EYELIDS
OPEN. GET MEDICAL ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING.
WASH WITH SOAP AND WATER. IF IRRITATION PERSIST, GET MEDICAL
ATTENTION. INH ALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. GET
MEDICAL ATTENTION. INGESTION: DO NOT INDUCE VOMITING. IF OCCURS,
KEEP HEAD BELOW HIPS. GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:293F,145C
Autoignition Temp:Autoignition Temp Text:>400F
Lower Limits:0.9 %
Upper Limits:7 %
Extinguishing Media:FOAM, WATER SPRAY (FOG), DRY CHEMICAL, CARBON
DIOXIDE AND VAPORIZING LIQUID TYPE EXTINGUISHING AGENTS.
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING, INCLUDING
HELMET, SELF-CONTAINED BREATHING APPARATUS, WHEN FIGHTING A
CHEMICAL FIRE. USE WATER SPRAY TO KEEP CONTAINERS COOL.
Unusual Fire/Explosion Hazard:FIRE MAY PRODUCE HAZARDOUS AND/OR TOXIC
DECOMPOSITION PRODUCTS.
================== Accidental Release Measures ==================
Spill Release Procedures:RECOVER FREE PRODUCT. ADD SAND, EARTH OR OTHER
SUITABLE ABSORBENT MATERIAL TO SPILL AREA. MINIMIZE SKIN CONTACT.
KEEP PRODUCT OUT OF SEWERS AND WATERCOURSES. ADVISE SUTHORITIES IF
PRODUCT HAS ENTERED SEWERS OR WATERCOURSES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS CLOSED WHEN NOT IN
USE. DO NOT STORE NEAR HEAT, SPARKS, FLAME OR STRONG OXIDANTS.
MINIMIZE BREATHING VAPOR, MIST OR FUMES.
Other Precautions:AVOID PROLONGED OR REPEATED CONTACT WITH SKIN. REMOVE
AND LAUNDER CONTAMINATED CLOTHING BEFORE RE-USE. REMOVE
CONTAMINATED SHOES AND THOROUGHLY CLEAN; DISCARD IF OIL SOAKED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE SUPPLIED-AIR RESPIRATORY PROTECTION IN
CONFINED OR ENCLOSED SPACES IF NEEDED.
Ventilation:USE LOCAL EXHAUST TO CAPTURE VAPOR, MISTS OR FUMES, IF
NECESSARY. PROVIDE VENTILATION SUFFICIENT TO MAINTAIN TLVS.
Other Protective Equipment:USE CHEMICAL-RESISTANT APRON OR OTHER
IMPERVIOUS CLOTHING IF NEEDED TO AVOID CONTAMINATING REGULAR
CLOTHING.
Work Hygienic Practices:WASH HANDS THOROUGHLY WITH SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES.
Supplemental Safety and Health
NON-PCB OIL CONTAINED IN COMPOUND-PRESSURE GAGE. EMPTY CONTAINERS
RETAIN RESIDUE AND CAN BE DANGEROUS. DO NOT PRESSURIZE, CUT, WELD,
BRAZE, SOLDER, DRILL, GRIND OR EXPOSE SUCH CONTAINERS TO HEAT, FLAM
E, SPARKS, STATIC ELECTRICITY OR OTHER SOURCES OF IGNITION. THEY
MAY EXPLODE AND CAUSE INJURY OR DEATH.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:460F,238C
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Vapor Pres:< 0.01
Vapor Density:NOT GIVEN
Spec Gravity:0.873
pH:7
Evaporation Rate & Reference:< 0.01 (BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR WATER-WHITE LIQUID WITH FAINT PETROLEUM
HYDROCARBON ODOR
Percent Volatiles by Volume:NIL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
LIQUID CHLORINE, CONCENTRATED OXYGEN, SODIUM HYPOCHLORITE OR CALCIUM
HYPOCHLORITE.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:FUMES, SMOKE, CARBON MONOXIDE, SULFUR
OXIDES, ALDEHYDES AND OTHER DECOMPOSITION PRODUCTS IN CASE OF
INCOMPLETE BURNING.
==================== Disposal Considerations ====================
Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT, RESIDUE, DISPOSAL CONTAINER OR
LINER IN ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:LUSTER PLUS ALMOND
CAGE:13374
CAGE:13374
CAGE:06758
============= Composition/Information on Ingredients =============
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: <1%
Other REC Limits:NONE SPECIFIED
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
Ingred Name:AMMONIA (SARA III)
CAS:7664-41-7
RTECS #:BO0875000
Fraction by Wt: <1%
Other REC Limits:NONE SPECIFIED
OSHA PEL:50 PPM
ACGIH TLV:25 PPM/35 STEL; 9293
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:ETHYLENE GLYCOL (SARA III)
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: 5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:C 50 PPM
ACGIH TLV:C 50 PPM,VAPOR; 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: <1%
Other REC Limits:NONE SPECIFIED
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 15%
Other REC Limits:NONE SPECIFIED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:ESTER-ALCOHOL
CAS:25265-77-4
Fraction by Wt: 1%
Other REC Limits:NONE SPECIFIED
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 55%
Other REC Limits:NONE SPECIFIED
Ingred Name:VINYL ACRYLIC RESIN
CAS:25067-01-0
Fraction by Wt: 15%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYE,SKIN AND LUNG IRRITATION
MAY OCCUR WITH OVEREXPOSURE. CONTINUED BREATHING OF VAPORS MAY
IRRITATE RESPIRATORY TRACT CAUSING HEADACHE, NAUSEA AND DIZZINESS.
THIS PRODUCT MAY BE FATAL FROM SWA LLOWING LARGE AMOUNTS. MAY CAUSE
NAUSEA, VOMITING, HEADACHES, DIZZINESS, STUPOR, AND KIDNEY DAMAGE.
Explanation of Carcinogenicity:NONE OF THE COMPOUNDS IN THIS PRODUCT IS
LISTED BY IARC, NTP, OR OSHA AS A SUSPECTED OR KNOWN CARCINOGEN.
Effects of Overexposure:EYE, SKIN AND LUNG IRRITATION. CONTINUED
BREATHING OF VAPORS MAY IRRITATE RESPIRATORY TRACT CAUSING
HEADACHE, NAUSEA AND DIZZINESS. THIS PRODUCT MAY BE FATAL FROM
SWALLOWING LARGE AMOUNTS. MAY CAUSE N AUSEA, VOMITING, HEADACHES,
DIZZINESS, STUPOR, AND KIDNEY DAMAGE.
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF AILMENTS
OR WITH A PRE-EXISTING DISEASE INVOLVING THE EYES, SKIN,
RESPIRATORY TRACT OR KIDNEY MAY BE AT INCREASED RISK FROM EXPOSURE.
======================= First Aid Measures =======================
First Aid:INHALATION:REMOVE TO FRESH AIR. EYES: IMMEDIATELY FLUSH WITH
PLENTY OF WATER FOR 15 MINUTES HOLDING EYELIDS OPEN. GET MEDICAL
ATTENTION. SKIN: WASH WITH SOAP AND WATER.INGESTION: INDUCE
VOMITING. GIVE 1 OR 2 GLASSES OF WATER IF CONSCIOUS. GET IMMEDIATE
MEDICAL HELP.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:205F,96C
Lower Limits:2.00
Upper Limits:15.00
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED
CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR APPROPRIATE PERSONAL PROTECTION
EQUIPMENT. CONTAIN SPILL WITH INERT ABSORBENT MATERIAL AND PUT INTO
VAPOR TIGHT CONTAINERS. PREVENT MATERIAL FROM CONTACTING ANY WATER
SOURCES OR STORM SEWERS.
Neutralizing Agent:NOT APPLICABLE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COMPLIANCE WITH GOOD
HOUSEKEEPING PROCEDURES. PROTECT FROM FREEZING, STORE AT
TEMPERATURES ABOVE 45 F. PROTECT FROM PHYSICAL DAMAGE.
Other Precautions:DO NOT TAKE INTERNALLY. DO NOT BREATHE MIST. AVOID
PROLONGED OR REPEATED BREATHING OF VAPOR. AVOID CONTACT WITH EYES.
USE WITH ADEQUATE VENTILATION. WASH THOROUGHLY AFTER HANDLING. READ
MANUFACTURER'S SAFETY PRECAUTIONS BEFORE USE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATORS TO REMOVE
SOLID AIRBORNE PARTICLES OF OVER SPRAY DURING SPRAY APPLICATIONS.
IN RESTRICTED VENTILATION AREAS USE NIOSH/MSHA APPROVED RESPIRATOR
DESIGNED TO REMOVE BO TH PARTICLES AND VAPOR.
Ventilation:SUFFICIENT VENTILATION IN VOLUME AND PATTERN SHOULD BE
PROVIDED TO KEEP AIR CONTAMINATION BELOW OSHA'S CURRENT PELS.
Other Protective Equipment:PREVENT PROLONGED SKIN CONTACT BY USING
CLEAN WORK CLOTHING, INCLUDING A HAT.
Work Hygienic Practices:WASH HANDS BEFORE EATING, SMOKING OR USING
WASHROOM FACILITIES. DO NOT WEAR CONTAMINATED CLOTHING OR FOOTWEAR.
Supplemental Safety and Health
DO NOT HANDLE UNTIL MANUFACTURES SAFETY PRECAUTIONS HAVE BEEN READ AND
UNDERSTOOD. PROVIDE ADEQUATE VENTILATION OR RESPIRATORY PROTECTION
TO REMOVE DECOMPOSITION PRODUCTS DURING WELDING OR FLAME CUTTI NG
COATED SURFACES. DO NOT STORE OR USENEAR HEAT, SPARKS, OR FLAMES.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:24.0
Vapor Density:7.4
Spec Gravity:1.18
Evaporation Rate & Reference:.4
Solubility in Water:APPRECIABLE
Appearance and Odor:NORMAL FOR A COATINGS PRODUCT
Percent Volatiles by Volume:72.74
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER-REACTIVE MATERIALS
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:MAY PRODUCE HAZARDOUS FUMES, INCLUDING
CARBON DIOXIDE AND CARBON MONOXIDE, WHEN HEATED.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL SHOULD BE MADE IN ACCORDANCE WITH ALL
APPLICABLE FEDERAL, STATE AND LOCAL LAWS AND REGULATIONS. DO NOT
INCINERATE CLOSED CONTAINERS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SEALED NICKEL-CADMIUM ACCUMULATOR
Preparer's Name:DR. J.WOIDT-Q.A. MGR.
CAGE:D8034
CAGE:D8034
============= Composition/Information on Ingredients =============
Ingred Name:NICKEL HYDROXIDE (SARA III)
CAS:12054-48-7
RTECS #:QR7040000
Fraction by Wt: 11-13.5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1 MG(NI)/M3
ACGIH TLV:0.1 MG(NI)/M3; 9394
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:NICKEL (SARA III)
CAS:7440-02-0
RTECS #:QR5950000
Fraction by Wt: 10-27%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3; 9394
Ingred Name:CADMIUM (AS CD);(SARA III)
CAS:7440-43-9
RTECS #:EU9800000
Fraction by Wt: 20-21%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.2 MG/M3 DUST; Z-2
ACGIH TLV:0.01 MG/M3 DUST;9394
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:POTASSIUM HYDROXIDE,50%(AQ) (SARA III);DENSITY AT 20C(68F)
IS 1.3 KG/L
CAS:1310-58-3
RTECS #:TT2100000
Fraction by Wt: 10%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:C, 2 MG/M3
ACGIH TLV:C 2 MG/M3; 9394
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD 50 ORAL RAT IS UNKNOWN FOR MIXTURE.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:NO EXPOSURE EXPECTED UNDER NORMAL
CONDITIONS OF USE. IF BATTERY RUPTURES, CONTACT MAY CAUSE BURNS.
Explanation of Carcinogenicity:NICKEL AND CADMIUM ARE LISTED UNDER IARC
AND NTP. NO EXPOSURE EXPECTED UNDER NORMAL CONDITIONS OF USE.
Effects of Overexposure:NO EXPOSURE EXPECTED UNDER NORMAL CONDITIONS OF
USE. IF CONTACTED WHEN BATTERY RUPTURE, IT MAY CAUSE BURNS TO EYES
AND SKIN.
======================= First Aid Measures =======================
First Aid:IF LEAKAGE FROM BATTERY CONTACT EYES: FLUSH IF PLENTY OF
WATER FOR AT LEAST 15 MINUTES, SEE DOCTOR IMMEDIATELY. SKIN: FLUSH
WITH PLENTY OF WATER. WASH WITH SOAP AND WATER. IF IRRITATION
PERSISTS, GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:NON-FLAMMABLE. USE EXTINGUISHING MEDIA APPROPIATE
FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED
CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:CONTACT WITH STRONG OXIDIZERS MAY CAUSE
FIRE OR EXPLOSION. MAY BURST WHEN SUBJECT TO EXTREME HEAT. CADMIUM
FUMES OR VAPORS ARE TOXIC AND CAN CAUSE DEATH.
================== Accidental Release Measures ==================
AND SAFETY GLASSES. COLLECT ALL RELEASED MATERIAL IN A PLASTIC BAG
FOR WASTE DISPOSAL. WASH AREA WITH PLENTY OF WATER.
Neutralizing Agent:DILUTE BORIC ACID.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY PLACE. PROTECT FROM
PHYSICAL DAMAGE, HEAT, FLAMES AND INCOMPATIBLE MATERIALS.
Other Precautions:DO NOT SHORT CIRCUIT BATTERIES. THEY MAY CAUSE BURNS
WHEN IN CONTACT WITH SKIN OR EYES. USE PROPER BATTERY CHARGER.
OBSERVE CORRECT POLARITY.
============= Exposure Controls/Personal Protection =============
Other Protective Equipment:PROTECTIVE CLOTHING,AS NEEDED.PROVIDE A
LOCAL EYE WASH STATION AND SAFETY SHOWER.
Work Hygienic Practices:NORMAL PRACTICES AND PROCEDURES.
Supplemental Safety and Health
NONE.
================== Physical/Chemical Properties ==================
HCC:N1
Solubility in Water:52% (KOH)
Appearance and Odor:CAUSTIC ELECTROLYTE IN BATTERY CASE.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, NITRATES, NITRIC ACID. BATTERY MAY SHORT
CIRCUIT IN WATER.
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES.
Hazardous Decomposition Products:METAL OXIDE FUMES MAY BE EVOLVED AT
TEMPERATURES ABOVE MELTING POINT.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTACT YOUR LOCAL ENVIRONMENTAL OFFICER.
DISPOSE OF IN ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL
REGULATIONS. DO NOT INCINERATE OR DISPOSE OF WITH HOUSEHOLD TRASH.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ENTEC CPS-1
CAGE:HO456
CAGE:HO456
CAGE:57394
============= Composition/Information on Ingredients =============
Ingred Name:ETHYLENEDIAMINE TETRAACETIC ACID TETRA SODIUM SALT
CAS:64-02-8
RTECS #:AH5075000
Fraction by Wt:
OSHA PEL:
ACGIH TLV:
===================== Hazards Identification =====================
LD50 LC50 Mixture:N/K
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN:PRIMARY ROUTE OF EXPSR MODERATELY
IRRITATING TO SKIN. EYE:SEVER IRRITANT. INHAL:MISTS/AEROSOLS CAUSE
IRRITATION TO UPPER RESPIRATORY TRACT,PROLONGED OR REPEATED CONTACT
MAY CAUSE PRIMARY IRRITANTDERMATITIS.
Explanation of Carcinogenicity:N/A
Effects of Overexposure:MAY CAUSE REDNESS OR ITCHING OF SKIN
Medical Cond Aggravated by Exposure:NOT KNOWN
======================= First Aid Measures =======================
First Aid:SKIN REMOVE CONTAM CLOTHING. WASH EXP AREA WITH LG AQUANITY
OF SOAP SOLN OR H*2O FOR 15 MINUTES. EYE:IMMEDIATELY FLUSH EYES
WITH H*2O FOR 15 MINUTES CONTACT PHYS. INHAL: REMOVE VICTIM FROM
CONTAM AREA TO FRESH AIR. APPLY APPROPRIATE FIRST AID TREATMENT AS
NECESSARY. INGEST: DO NOT INDUCE VOMITING. IMMED CONTACT PHYS. GIVE
3-4 GLASSES MILK OR H*2O.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:>200F 93.33C
Lower Limits:
Upper Limits:
Extinguishing Media:DRY CHEMICAL,CARBON DIOXIDE,FOAM OR N*20. FOAM OR
H*2O CREATE A SLIPPERY CONDITION,SPREAD SAND OR GRIT.
Fire Fighting Procedures:FIREFIGHTERS SHOULD WEAR POSITIVE PRESSURE
SCBA FULL FACE-PIECE TYPE. USE NIOSH/MSHA APPROVED SCBA FULL
PROTECTIVE EQUIPMENT
Unusual Fire/Explosion Hazard:N/K
================== Accidental Release Measures ==================
Spill Release Procedures:VENT AREA USE SPECIFIC PROT EQUIP. CONT &
ABSORB ON ABSORBENT MAT.PLACE IN WASTE.DISPOSAL CNTNR.THE WASTE
CHARACTERISTIC OF THE ABSORED MAT OR ANY CONTAM SOIL SHOULD BE
DETERMINED IAW RCRA REGS. FLUSH AREA W/H*2O.WET AREA MAY BE
SLIP.SPREAD SAND GRIT
Neutralizing Agent:
======================Handling and Storage ======================
Handling and Storage Precautions:KEE CONTAINER CLOSED PROTECT FROM
FREEZING.IMMEDIATELY REMOVE CONTM CLOTHING WASH BEFORE
REUSE,ALKALINE CROSSIVE TO EYE,DON'T MIX WITH ACIDIC MATERIAL
Other Precautions:N/K
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF VENT IS INADEQUATE OR SIGNIFICANT PRODUCT
EXPOSURE IS LIKELY USE A RESPIRATOR WITH DUST MIST CARTRIDGES (MFR)
Ventilation:ADEQUATE VENT TO MAINTAIN CONTAM BELOW EXPOSURE LIMITS.
Other Protective Equipment:N/K
Work Hygienic Practices:OBSERVE GOOD WORK HYGIENIC PRACTICES
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:N/K
Melt/Freeze Pt:M.P/F.P Text:
Decomp Temp:Decomp Text:
Vapor Pres:ND
Vapor Density:ND
Spec Gravity:1.169
pH:13.0
Evaporation Rate & Reference:<1 ETHER=1
Solubility in Water:100
Appearance and Odor:MILD
Percent Volatiles by Volume:
Corrosion Rate:
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:N/K
Hazardous Decomposition Products:THERMAL DECOMPOSTION (DESTRUCTIVE
FIRES) YIELDS ELEMENTAL OXIDES
==================== Disposal Considerations ====================
Waste Disposal Methods:H*2O CONTM WITH THIS PRODUCT MAY BE SENT TO A
SANITARY SEWER TREATMENT FACILITY IN ACCORDANCE WITH LOCAL
AGREEMENTS INCINERATE OR BURY IN APPROVED LANDFILL
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:15426,SCOURGE INSECTICIDE WITH SBP-1382/PB4%+12% (SEE SUPPL)
Resp. Party Other MSDS Num.:C3420
Preparer's Name:NOT PROVIDED
CAGE:UO368
CAGE:UO368
============= Composition/Information on Ingredients =============
Ingred Name:RESMETHRIN
CAS:10453-86-8
RTECS #:GZ1310000
= Wt:4.14
Other REC Limits:NOT PROVIDED
OSHA PEL:NOT PROVIDED
ACGIH TLV:NOT PROVIDED
Ingred Name:PIPERONYL BUTOXIDE
CAS:51-03-6
RTECS #:XS8050000
= Wt:12.42
Other REC Limits:NOT PROVIDED
OSHA PEL:NOT PROVIDED
ACGIH TLV:NOT PROVIDED
Ingred Name:OTHER INGREDIENTS, INCLUDING NEXT INGREDIENT
= Wt:83.44
Other REC Limits:NOT PROVIDED
OSHA PEL:NOT PROVIDED
ACGIH TLV:NOT PROVIDED
Ingred Name:AROMATIC PETROLEUM SOLVENT
CAS:64742-94-5
RTECS #:WF3100000
Fraction by Wt: SEE ING#3%
Other REC Limits:100 PPM (MFR)
OSHA PEL:NOT PROVIDED
ACGIH TLV:NOT PROVIDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NOT PROVIDED
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:POTENTIAL HEALTH EFFECTS: IMMEDIATE
EFFECTS: SKIN: HARMFUL IF ABSORBED THROUGH SKIN. INGESTION: HARMFUL
IF SWALLOWED.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:TRANSIENT HEADACHE, DIZZINESS, STUFFY OR RUNNY
NOSE, AND SCRATCHY THROAT.
Medical Cond Aggravated by Exposure:NONE KNOWN
======================= First Aid Measures =======================
First Aid:AFTER CONTACT WITH SKIN: WASH WITH SOAP AND PLENTY OF WATER.
GET MEDICAL ATTENTION. AFTER CONTACT WITH EYES: FLUSH EYES WITH
PLENTY OF WATER. GET MEDICAL ATTENTION IF IRRITATION PERSISTS.
AFTER INGEST ION: CALL A DOCTOR OR GET MEDICAL ATTETNION. DO NOT
INDUCE VOMITING. DO NOT GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS
PERSON. AVOID ALCOHOL. THIS PRODUCT CONTAINS AROMATIC PETROLEUM
SOLVENT. ASPIRATION MAY BE A HAZARD.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:>93.3C, 200.F
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL OR FOAM. COOL
CONTAINERS WITH WATER FROM AS FAR A DISTANCE AS POSSIBLE.
Fire Fighting Procedures:AS IN ANY FIRE, WEAR SELF-CONTAINED BREATHING
APPARATUS PRESSURE-DEMAND, MSHA/NIOSH APRROVED (OR EQUIVALENT) AND
FULL PROTECTIVE GEAR. KEEP UPWIND. ISOLATE HAZARD AREA. AVOID
INHALATION OF SMOKE AND FUMES. USE WATER OR FOAM TO REDUCE FUMES.
DO NOT TOUCH SPILLED MATERIAL. IF POSSIBLE, MOVE CONTAINERS FROM
AREA.
Unusual Fire/Explosion Hazard:NOT PROVIDED
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL SPILL: ABSORB WITH AN INERT MATERIAL AND
PUT IN AN APPROPRIATE WASTE DISPOSAL CONTAINER. RINSE SPILL AREA
WITH SOAP AND WATER. LARGE SPILL: ELIMINATE ALL IGNITION SOURCES.
STOP LEAK IF YOU CAN D O WITHOUT CONTACT. DIKE FAR AHEAD. GROUND
ALL EQUIPMENT. PREVENT ENTRY INTO SEWERS, BASEMENTS OR CONFINED
AREAS. INFORM AUTHORITIES IMMEDIATELY IF CONTAMINATION OCCURS. USE
PROPER PROTECTIVE EQUIPMENT
Neutralizing Agent:NOT RELEVANT
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT CONTAMINATE WATER, FOOD OR FEED
BY STORAGE. STORE PRODUCT IN ORIGINAL CONTAINER IN A LOCKED STORAGE
AREA.
Other Precautions:AVOID CONTACT WITH SKIN, EYES, OR CLOTHING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:ENSURE GOOD VENTILATION. IF NOT ADEQUATE, USE A
CHEMICAL CARTRIDGE-TYPE RESPIRATOR APPROVED BY THE NATIONAL
INSTITUTE OF OCCUPATIONAL HEALTH AND SAFETY.
Ventilation:CONTROL AIRBORNE CONCENTRATIONS BELOW THE APPROPRIATE
EXPOSURE GUIDELINES. LOCAL EXHAUST VENTILATION MAY BE NECESSARY.
Other Protective Equipment:EYE WASH FACILITY AND SAFETY SHOWER SHOULD
BE AVAILABLE. OTHER PROTECTIVE CLOTHING TO AVOID SKIN CONTACT.
Work Hygienic Practices:WASH THOROUGHLY WITH SOAP AND WATER AFTER
HANDLING.
Supplemental Safety and Health
CONTD FROM PRODUCT ID: MF FORMULA II. ABBREVIATION: N/A = NOT
APPLICABLE. N/AV = NOT AVAILABLE. N/K = UNKNOWN. N/P = NOT
PROVIDED. N/R = NOT RELEVANT. N/D = NOT DETERMINED. N/E = NOT
ESTABLISHED. CNS = CENTRAL NERVOUS SYSTEM. GI = GASTROINTESTINAL.
SCBA = SELF CONTAINED BREATHING APPARATUS.
================== Physical/Chemical Properties ==================
HCC:T5
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:NOT AVAILABLE
Melt/Freeze Pt:M.P/F.P Text:NOT AVAILABLE
Decomp Temp:Decomp Text:NOT PROVIDED
Vapor Pres:NOT AVAILABLE
Vapor Density:N/AV
Spec Gravity:0.87 G/CM3@22C
Viscosity:[email protected]
Solubility in Water:INSOLUBLE
Appearance and Odor:APPEARANCE: A GOLDEN, ABMER LIQUID. ODOR: A MILD
SOLVENT ODOR.
Percent Volatiles by Volume:NOT PROVIDED
Corrosion Rate:NOT PROVIDED
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AND STRONG REDUCING AGENTS
Stability Condition to Avoid:EXTREME HEAT OR SOURCES OF IGNITION
Hazardous Decomposition Products:THERMAL DECOMPOSITION PRODUCTS MAY
INCLUDE CARBON MONOXIDE AND CARBON DIOXIDE.
=================== Toxicological Information===================
Toxicological Information:THERE ARE NO ACUTE TOXICOLOGICAL DATA
AVAILABLE FOR THIS FORMULATION. ACUTE TOXICITY FOR A FORMULA
CONTAINING RESMETHRIN 18% AND PIPERONYL BUTOXIDE OF 54% SHOWED ORAL
LD50 (RAT): 2,700 MG/KG (SLIGHTLY TOXIC). DERMAL LD50 (RABBIT): >
2,000 MG/KG (SLIGHTLY TOXIC). INHALATION LC50 (RAT, 4 HR): > 2.64
MG/L (PRACTICALLY NON-TOXIC).
===================== Ecological Information =====================
Ecological:THIS PESTICIDE IS HIGHLY TOXIC TO FISH. FOR TERRESTRIAL USE,
DO NOT APPLY DIRECTLY TO WATER, TO AREAS WHERE SURFACE WATER IS
PRESENT OR TO INTERTIDAL AREAS BELOW THE MEAN HIGH WATER MARK.
DRIFT AND RU NOFF FROM TREATED SITES MAY BE HAZRDOUS TO FISH IN
ADJACENT WATER. CONSULT YOUR STATE'S FISH AND WILDLIFE AGENCY
BEFORE TREATING SUCH WATERS. DO NOT CONTAMINATE WATER BY CLEANING
OF EQUIPMENT OR DISPO SAL OF EQUIPMENT WASH WATERS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT CONTAMINATE WATER, FOOD OR FEED BY
DISPOSAL. WASTES RESULTING FROM THE USE OF THIS PRODUCT MAY BE
DISPOSED OF ON SITE OR AT AN APPROVED WASTE DISPOSAL FACILITY.
TRIPLE RINSE CONTAINER. THEN OFF ER FOR RECYCLING OR RECONDITIONING
OR PUNCTURE AND DISPOSE OF IN A SANTIRAY LANDFILL OR BY OTHER PRO
CEDURES APPROVED BY STATE AND LOCAL AUTHORITIES.
=================== MSDS Transport Information ===================
Transport Information:PROPER SHIPPING NAME: NOT DOT REGULATED. NOTE:
SCOURGE 4% + 12% IS NOT REGULATED FOR DOMESTIC SHIPMENTS IF IT IS
CONTAINED IN A BULK CARRIER AND GREATER THAN OR EQUAL 110 GALLONS
THEN: COMBUSTIBLE LIQ UIDS, N.O.S. NA1993. NOTE: FOR TRANSPORT
PURPOSES (49 CFR PART 173.132), THE CALCULATED 1-HOUR LC50 (RAT)
IS: > 10.56 MG/L.
===================== Regulatory Information =====================
SARA Title III Information:SARA TITLE I I I SECTION 311/312 HAZARD
CLASSES: ACUTE HEALTH HAZARD: YES. CHRONIC HEALTH HAZARD: YES. FIRE
HAZARD: NO. SUDDEN RELEASE OF PRESSURE HAZARD: NO. REACTIVE HAZARD:
NO. SARA TITLE III, NOT IFICATION AND INFORMATION SECTION 302 (EHS)
INGREDIENTS: NONE. SECTION 304 (CERCLA & EHS) INGREDIENTS (RQ):
NONE. SARA 313: RESMETHRIN 4.14% (10453-86-8), PIPERONYL BUTOXIDE
12.42% (51-03-6).
Federal Regulatory Information:EPA REGISTRATION NUMBER: 432-716. TSCA
INVENTORY STATUS: THESE COMPONENTS ARE NOT LISTED:RESMETHRIN
4.14% (10453-86-8), OTHER INGREDIENTS, INCLUDING: 83.44 %
State Regulatory Information:CALIFORNIA PROPOSITION 65: THIS PRODUCT
CONTAINS A CHEMICAL (RESMETHRIN) KNOWN TO THE STATE OF CALIFORNIA
TO CAUSE CANCER, BIRTH DEFECT OR OTHER REPRODUCTIVE HARM. THE
FOLLOWING CHEMICALS ASSOCIATED W ITH THE PRODUCT ARE SUBJECT TO THE
RIGHT-TO-KNOW REGULATIONS IN THESE STATES: RESMETHRIN (10453-86-8):
NJ AND PIPERONYL BUTOXIDE (51-03-6): NJ.
======================= Other Information =======================
| 1 | gloves_mandatory |
=======================================================
NIIN: 01-336-5060
Product ID: ECO SURE GRAY 16081 GLOSS VOC-COMPLIANT SPR
Cage: 0FTT5
=======================================================
Preparer Co. when other than Responsible Party Co.
=======================================================
Cage: 0FTT5
=======================================================
Contractor Summary
=======================================================
Cage: 0FTT5
=======================================================
Item Description Information
=======================================================
Item Manager: GSA
Item Name: ENAMEL
Specification Number: A-A-2787
Unit of Issue: PT
UI Container Qty: 0
=======================================================
Ingredients
=======================================================
Cas: 1330-20-7
RTECS #: ZE2100000
% Wt: <19.84
Other REC Limits: NONE SPECIFIED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: 100 PPM
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
------------------------------
Cas: 110-12-3
RTECS #: MP3850000
% Wt: 5.83
Other REC Limits: NONE SPECIFIED
OSHA PEL: 100 PPM
ACGIH TLV: 50 PPM; 9293
------------------------------
Cas: 64742-95-6
RTECS #: SE7546500
% Wt: <2.92
Other REC Limits: NONE SPECIFIED
OSHA PEL: 5 PPM
ACGIH TLV: 5 PPM
------------------------------
Cas: 64742-95-6
RTECS #: SE7546500
% Wt: 5.83
Other REC Limits: NONE SPECIFIED
OSHA PEL: 50 PPM
ACGIH TLV: 50 PPM
------------------------------
Cas: 108-10-1
RTECS #: SA9275000
% Wt: 2.92
Other REC Limits: NONE SPECIFIED
OSHA PEL: 100 PPM/75 STEL
ACGIH TLV: 50 PPM/75 STEL; 9293
EPA Rpt Qty: 5000 LBS
DOT Rpt Qty: 5000 LBS
------------------------------
Cas: 107-87-9
RTECS #: SA7875000
% Wt: 2.92
Other REC Limits: NONE SPECIFIED
OSHA PEL: 200 PPM
ACGIH TLV: 200 PPM
------------------------------
Cas: 95-63-5
RTECS #: DC3325000
% Wt: <2.92
Other REC Limits: NONE SPECIFIED
OSHA PEL: 25 PPM
ACGIH TLV: 25 PPM
-----------------------------
Cas: 74-98-6
RTECS #: TX2275000
% Wt: 15.12
Other REC Limits: NONE SPECIFIED
OSHA PEL: 1000 PPM
ACGIH TLV: 1000 PPM
------------------------------
Cas: 75-28-5
RTECS #: TZ4300000
% Wt: 5.95
Other REC Limits: NONE SPECIFIED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: 800 PPM
------------------------------
Cas: 106-97-8
RTECS #: EJ4200000
% Wt: 3.72
Other REC Limits: NONE SPECIFIED
OSHA PEL: 800 PPM
ACGIH TLV: 800 PPM
------------------------------
RTECS #: 9999999VO
Other REC Limits: NONE SPECIFIED
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: ORAL LD50 (RAT) IS UNKNOWN
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: CONCENTRATING & INHALING CONTENTS-HARMFUL/FATAL.
REPEATED & PROLONGED OCCUPATIONAL OVEREXPOSURE TO SOLVENTS: PERMANENT
BRAIN & NERVOUS SYSTEM DAMAGE. HIGH VAPOR CONCENTRATIONS: ANESTHETIC.
SKIN & RESP TRACT IRRITATION. OVEREXPOSURE: LIGHT HEADEDNESS,
STAGGERING, GIDDINESS, NAUSEA. HARMFUL IF INGESTED. SEVERE EYE IRRIT.
Signs And Symptions Of Overexposure: IRRITATION TO EYES, THROAT AND RESPIRATORY
TRACT. MAY CAUSE HEADACHES, NAUSEA, AND VOMITING.
Medical Cond Aggravated By Exposure: RESPIRATORY AILMENTS
First Aid: FOR CONTACT WITH SKIN OR CLOTHES WASH WITH SOAP AND WATER; WASH
CLOTHES BEFORE REUSE. FOR CONTACT WITH EYES, FLUSH WITH WATER FOR 15 MINUTES
AND CONTACT A PHYSICIAN/OPHTHALMOLOGIST IMMEDIATELY. IF SWA LLOWED, DO NOT
INDUCE VOMITING. GET IMMEDIATE MEDICAL AID. IF INHALED, REMOVE TO FRESH AIR
& GIVE ARTIFICIAL RESPIRATION IF NEEDED. GET MED AID. NEVER GIVE ANYTHING
BY MOUTH TO AN UNCONSCIOUS PERSON.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: REMOVE ALL SOURCES OF IGNITION AND VENTILATE AREA.
MOP SPILLS WITH INERT ABSORBENT. AVOID BREATHING VAPORS.
Waste Disposal Methods: DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE &
LOCAL REGULATIONS. DONT PUNCTURE, INCINERATE OR STORE ABOVE 120F. EXPOSURE TO
HEAT/PROLONGED EXPOSURE TO SUN MAY CAUSE CAN TO BUST. DISCARD EMPTY CAN IN
TRASH PICK-UP. DONT PLACE IN HOME TRASHCOMPACTOR.
Handling And Storage Precautions: KEEP OUT OF REACH OF CHILDREN. CAUTION
CONTENTS UNDER PRESSURE. DO NOT STORE WHERE TEMPERATURES EXCEED 120F. AVOID
BREATHING SPRAY, MIST OR VAPOR.
Other Precautions: AVOID CONTACT WITH EYES OR SKIN. USE WITH GOOD VENTILATION.
READ ENTIRE LABEL BEFORE USING. FOLLOW ALL LABEL DIRECTIONS. INTENTIONAL
MISUSE BY DELIBERATELY CONCENTRATING AND INHALING OR SWALLOWING CON TENTS MAY
BE HARMFUL OR FATAL.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: NR
Autoignition Temp Text: 874 F
Lower Limits: 1.8
Upper Limits: 9.5
Extinguishing Media: CARBON DIOXIDE, DRY CHEMICAL, FOAM, SAND, WATER SPRAY.
AVOID SPREADING ANY BURNING LIQUID WITH WATER SPRAY.
Fire Fighting Procedures: WATER MAY BE INEFFECTIVE, USE TO KEEP FIRE EXPOSED
CONTAINERS COOL. WEAR SCBA. USE SHIELDING TO PROTECT PERSONNEL AGAINST
BURSTING, RUPTURING, VENTING OF CNTNR.
Unusual Fire/Explosion Hazard: DO NOT SPRAY NEAR OPEN FLAME. AT ELEVATED
TEMPERATURES (OVER 120F) CONTAINERS MAY VENT, RUPTURE OR BURST. AEROSOL
CONTAINER, DO NOT EXPOSE TO TEMPS ABOVE 120 F.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NONE BELOW TLV. USE NIOSH/MSHA APPROVED MASK ABOVE TLV.
Ventilation: LOCAL EXHAUST PREFERRED. MECHANICAL (GENERAL) ACCEPTABLE AT POINT
OF MIST OR SPRAY RELEASE.
Other Protective Equipment: IMPERVIOUS CLOTHES TO PROTECT SKIN. EYE WASH
STATION.
Work Hygienic Practices: USE GOOD PERSONAL HYGIENE. DO NOT EAT, DRINK OR SMOKE
WHILE USING PRODUCT.
=======================================================
Physical/Chemical Properties
=======================================================
HCC: V3
Vapor Pres: 60
Vapor Density: >1.5
Spec Gravity: .997 (WATER=1)
Solubility in Water: INSOLUBLE
Appearance and Odor: GRAY/PAINT
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: EXTREME HEAT
Hazardous Decomposition Products: CARBON MONOXIDE
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
Transportation Information
=======================================================
Trans ID NO: 126911
Product ID: ECO SURE GRAY 16081 GLOSS VOC-COMPLIANT SPR
Review Date: 03/17/1993
Multiple KIT Number: 0
Review IND: Y
Unit Of Issue: PT
Container QTY: 0
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: DTJ
Symbols: D
DOT Proper Shipping Name: CONSUMER COMMODITY
Hazard Class: ORM-D
Label: NONE
Non Bulk Pack: 156,306
Bulk Pack: NONE
Max Qty Pass: 30KGGROSS
Max Qty Cargo: 30KGGROSS
Vessel Stow Req: A
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: AKH
IMO Proper Shipping Name: AEROSOLS/AEROSOL PRODUCT ?
IMDG Page Number: SEE 9022
UN Number: 1950
UN Hazard Class: 9?
IMO Packaging Group: -
Subsidiary Risk Label: -
EMS Number: 2-13
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: ALS
IATA UN ID Num: 1950
IATA Proper Shipping Name: AEROSOLS, FLAMMABLE
IATA PSN Modifier: (EACH NOT EXCEEDING 1 L CAPACITY)
IATA UN Class: 2.1
IATA Label: FLAMMABLE GAS
Packing Note Passenger: 203
Max Quant Pass: 75KG
Max Quant Cargo: 150KG
Packaging Note Cargo: 203
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: ALS
AFI Proper Shipping Name: AEROSOLS, NONFLAMMABLE, N.O.S.
AFI PSN Modifier: CONTAINING SUBSTANCES IN CLASS 8, PACKING GROUP I OR II
AFI Hazard Class: FORB
Back Pack Reference: FORBIDDEN
=======================================================
HAZCOM Label
=======================================================
Product ID: ECO SURE GRAY 16081 GLOSS VOC-COMPLIANT SPR
Cage: 0FTT5
Company Name: LHB INDUSTRIES
Street: 8833 FLEISCHER PLACE
Zipcode: 63134
Label Required IND: Y
Date Of Label Review: 12/16/1998
Status Code: C
Label Date: 12/16/1998
Origination Code: G
Hazard And Precautions: CONCENTRATING & INHALING CONTENTS-HARMFUL/FATAL.
REPEATED & PROLONGED OCCUPATIONAL OVEREXPOSURE TO SOLVENTS: PERMANENT
BRAIN & NERVOUS SYSTEM DAMAGE. HIGH VAPOR CONCENTRATIONS: ANESTHETIC.
SKIN & RESP TRACT IRRITATION. OVEREXPOSURE: LIGHT HEADEDNESS,
STAGGERING, GIDDINESS, NAUSEA. HARMFUL IF INGESTED. SEVERE EYE
IRRIT.IRRITATION TO EYES, THROAT AND RESPIRATORY TRACT. MAY CAUSE HEADACHES,
NAUSEA, A ND VOMITING.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PRIMER COATING GREEN 34079, K4-011
CAGE:DO165
CAGE:DO165
CAGE:5V430
============= Composition/Information on Ingredients =============
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 20-50%
OSHA PEL:200 PPM/300 STEL
ACGIH TLV:200 PPM/300STEL 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:AROMATIC SOLVENT
CAS:108-88-3
RTECS #:SX5250000
Fraction by Wt: 5-20%
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:DIACETONE ALCOHOL (4-HYDROXY-4-METHYL-2-PENTANONE)
CAS:123-42-2
RTECS #:SA9100000
Fraction by Wt: 5-20%
OSHA PEL:50 PPM
ACGIH TLV:50 PPM; 9192
Ingred Name:BUTYL BENZYL PHTHALATE (SARA III)
CAS:85-68-7
RTECS #:TH9990000
Fraction by Wt: 1-5%
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:ACETATES
CAS:108-65-6
RTECS #:AI8925000
Fraction by Wt: <1%.
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: <1%.
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:TOXICITY MAY CAUSE HEADACHE,
DIZZINESS, NAUSEA, AND LOSS OF CONSCIOUSNESS. EYE IRRITATION,
IRRITATED MUCOUS MEMBRANES, VOMITING DUE TO INGESTION, DEFATTING
AND DRYING OF THE SKIN
Effects of Overexposure:OVEREXPOSURE MAY PRODUCE VARIOUS EFFECTS-ACUTE
TOXICITY, EYE IRRITATION, IRRITATED MUCOUS MEMBRANES, VOMITING,
SKIN IRRITATION & DERMATITIS.
======================= First Aid Measures =======================
First Aid:DO NOT INDUCE VOMITING, EYE CONTACT-FLUSH EYES WITH WATER FOR
15 MINUTES, INHALATION - REMOVE VICTIM TO FRESH AIR AND PROVIDE
OXYGEN IF NECESSARY. KEEP VICTIM QUIET. SKIN CONTACT-FLUSH WITH
WATER-REMO VE CONTAMINATED CLOTHING, WASH WITH SOAP AND WATER. GET
MEDICAL ATTENTION IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:45F/-7.22C
Lower Limits:0.8
Extinguishing Media:FOAM, CO2, OR DRY CHEMICAL
Fire Fighting Procedures:WATER MAY BE USED TO KEEP EXPOSED CONTAINERS
COOL AND TO KEEP FLAMMABLE STRUCTURES WET. DO NOT ENTER FIRE AREA
W/O PROPER PROTECTION.
Unusual Fire/Explosion Hazard:SEALED CONTAINERS MAY EXPLODE IF
OVERHEATED. VAPORS MAY BE RELEASED WHEN HEATED ABOVE FLASH POINT.
MAY EXPLODE WHEN MIXED WITH AIR AND IGNITION SOURCE.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES. HANDLING
EQUIPMENT MUST BE GROUNDED TO PREVENT SPARKING. SEAL TIGHTLY FOR
PROPER DISPOSAL. SOAK UP WITH ABSORBENT AND PLACE IN NON LEAKING
CONTAINERS.
======================Handling and Storage ======================
Handling and Storage Precautions:TREAT AS A HAZARDOUS-FLAMMABLE
MATERIAL. KNOW APPLICABLE DOT REGULATIONS BEFORE ATTEMPTING TO
TRANSPORT THIS MATERIAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:MUST PROVIDE ADEQUATE VENTILATION TO KEEP VAPOR
CONCENTRATIONS BELOW ESTABLISHED TLV LIMIT.IN MORE CONFINED AREAS A
NIOSH-MSHA APPROVED RESPIRATOR EQUIPPED WITH ORGANIC VAPOR
CARTRIDGE SHOULD BE WORN.
Ventilation:MUST PROVIDE ADEQUATE VENTILATION
Other Protective Equipment:HAVE EYE BATH AVAILABLE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:175-698F
Vapor Density:>AIR
Evaporation Rate & Reference:3.44 X N-BUTYL ACETATE
Appearance and Odor:GREEN LIQUID
Percent Volatiles by Volume:67.1
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS AND STRONG ALKALIES.
Stability Condition to Avoid:AVOID HEAT, SPARKS, OPEN FLAMES AND
INCOMPATIBILITIES ABOVE HIGH TEMPERATURE, STRONG OXIDIZING
CONDITIONS.
Hazardous Decomposition Products:INCOMPLETE COMBUSTION FOR PRODUCTS
LIKE THIS MAY GENERATE HIGHLY POISONOUS CARBON MONOXIDE AND OTHER
TOXIC GASES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH CURRENT LOCAL, STATE
AND FEDERAL REGULATION. CONTACT AN APPROVED DISPOSAL FACILITY.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:COMPONENT 3 OF DECON I
CAGE:60737
CAGE:60737
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM HYDROXIDE (SARA III)
CAS:1310-73-2
RTECS #:WB4900000
Fraction by Wt: 5%
Other REC Limits:2MG/M3 CEILING NIOSH
OSHA PEL:2 MG/M3
ACGIH TLV:C 2 MG/M3; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: SEVERE DAMAGE & BLINDNESS. SKIN:
BURNS. INHALATION: INJURE THE ENTIRE RESPIRATORY TRACT. INGESTION:
SEVERE DAMAGE TO MUCOUS MEMBRANES & DEEP TISSUES.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES: SEVERE DAMAGE & BLINDNESS. SKIN: BURNS.
INHALATION: INJURE THE ENTIRE RESPIRATORY TRACT. INGESTION: SEVERE
DAMAGE TO MUCOUS MEMBRANES & DEEP TISSUES.
======================= First Aid Measures =======================
First Aid:EYES: PLENTY OF WATER FOR AT LEAST 15 MINUTES. CONTACT
PHYSICIAN. INHALATION: REMOVE FROM EXPOSED AREA & SEEK MED ATTN.
SKIN: WASH THE AFFECTED AREA W/LARGE QUANTITIES OF WATER-DILUTE
ACETIC ACID/VINE GAR TO NEUTRALIZE. REMOVE CONTAMINATED CLOTHING.
INGESTION: DRINK LARGE AMOUNTS OF WATER/MILK THEN NEUTRALIZE
W/DILUTE VINEGAR/FRUIT JUICE. DON'T INDUCE VOMITING. CALL
PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:DON'T USE WATER.
Fire Fighting Procedures:ALTHOUGH IT IS COMBUSTIBLE, IT CAN BE
HAZARDOUS IF PRESENT IN A FIRE AREA.
Unusual Fire/Explosion Hazard:MELT/FLOW WHEN HEATED. HOT/MOLTEN
MATERIAL CAN REACT VIOLENTLY W/WATER & CHEMICALLY REACTIVE METALS
WHICH CAN FORM EXPLOSIVE MIXTURES W/AIR. COMBUSTIBLE.
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN THE SPILLED MATERIAL. FLUSH
CONTAMINATED SURFACES W/WATER & NEUTRALIZE W/DILUTE ACID,
PREFERABLY ACETIC ACID.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID BREATHING DUSTS/MISTS & CONTACT
W/SKIN/EYES. STORE IN WELL-SEALED CONTAINERS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MESH APPROVED FILTER RESPIRATOR.
Ventilation:PROVIDE ADEQUATE MECHANICAL VENTILATION TO KEEP <TLV.
Other Protective Equipment:EYE WASH, SAFETY SHOWER
Supplemental Safety and Health
KEY1:C2.
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:1388C
Vapor Pres:1000C
Spec Gravity:2.13
Appearance and Odor:WHITE OR OFF-WHITE, HYGROSCOPIC SOLID W/APPRECIABLE
ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACID/ORGANICS/NITRO CARBONS/CHLOROCARBONS/TRICHLOROETHYLENE,
ALUMINUM, ZINC, MAGNESIUM, & COPPER
Stability Condition to Avoid:HEAT
Hazardous Decomposition Products:HYDROGEN GAS, FLAMMABLE
DICHLOROACETYLENE
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE CAUSTIC SHOULD BE DELIBERATELY DISCHARGED
TO SEWERS OR SURFACE WATERS. WASTE SHOULD BE CONVERTED TO A NEUTRAL
SALT & DILUTED WELL W/WATER. DISPOSE OF WASTE IN ACCORDANCE W/ALL
FEDERAL, STATE, & LOCAL REGULATIONS. DOT CORROSIVE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ZYTEL 101
CAGE:B0589
CAGE:B0589
CAGE:18873
============= Composition/Information on Ingredients =============
Ingred Name:POLYHEXAMETHYLENE ADIPAMIDE
CAS:32131-17-2
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:LUBRICANTS
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ADDITIVES (NON HAZARDOUS)
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:READ SECTION 12, SAFETY, IN ZYTEL
MOLDING GUIDE BULLETIN B-97221, BEFORE USING PRODUCT. ACUTE:
INGESTION:NOT PROBABLE ROUTE OF EXPOSURE. SKIN:MOLTEN POLYMER
CAUSES THERMAL BURNS. EYES: MECHANICAL IRRI TATION.
INHALATION:GRANULES NOT RESPIRABLE. CHRONIC:NO KNOWN EFFECTS.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD IMMEDIATELY . INHAL:IF EXPOSED TO FUMES FROM
OVERHEATING, MOVE TO FRESH AIR. CONSULT MD IF SYMPTOMS PERSIST.
SKIN: WASH WITH SOAP AND PLENTY OF WATER. IF MOLTEN POLYMER
CONTACTS S KIN, COOL RAPIDLY WITH COLD WATER. DO NOT ATTEMPT TO
PEEL POLYMER FROM SKIN. OBTAIN MEDICAL ATTENTION FOR THERMAL BURN.
EYES:FLUSH WITH WATER FOR AT LEAST 15 MINUTES. CONSULT MD IF
SYMPTOMS PERSIST.
===================== Fire Fighting Measures =====================
Flash Point:752F,400C
Extinguishing Media:WATER, CARBON DIOXIDE, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:LG MOLTEN MASSES MAY IGNITE SPONT IN AIR.
QUENCHING THEM W/WATER IS GOOD PRAC. HAZ COMBUST PROD:PRIMARILY
AMMONIA & CO; SM AMT OF HYDROGEN CYANIDE, ALDEHYDES.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP TO PREVENT A SLIPPING HAZARD.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY PLACE. KEEP
CONTAINERS TIGHTLY CLOSED TO PREVENT MOISTURE ABSORPTION AND
CONTAMINATION.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN . NONE UNDER NORMAL PROCESSING IF
VENTILATION IS ADEQUATE.
Ventilation:LOCAL EXHAUST AT PROCESSING EQUIPMENT TO KEEP PARTICULATE
BELOW 15 MG/M3 (OSHA LIMIT FOR NUISANCE DUSTS).
Other Protective Equipment:LONG SLEEVE COTTON SHIRT AND LONG PANTS IF
HANDLING MOLTEN POLYMER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:>482F,>250C
Spec Gravity:1.13-1.15
Solubility in Water:INSOLUBLE
Appearance and Odor:GRANULES, NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS AND OXIDIZING AGENTS.
Stability Condition to Avoid:HEATING ABOVE 340C.
Hazardous Decomposition Products:CYCLOPENTANONE AND CARBON MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:LANDFILL OR INCINERATION IN COMPLIANCE WITH
FEDERAL, STATE AND LOCAL REGULATIONS. AQUATIC TOXICITY IS EXPECTED
TO BE LOW BASED ON INSOLUBILITY OF POLYMER IN WATER.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:02592 EPDM WEATHERSTRIP
CAGE:82464
CAGE:82464
============= Composition/Information on Ingredients =============
Ingred Name:POLYETHYLNEPROPYLENEDIENE
Fraction by Wt: 100%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INGESTION: IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INGESTION: IRRITATION.
======================= First Aid Measures =======================
First Aid:INGESTION: DON'T INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN
ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:CO2, FOAM, DRY CHEMICAL, & WATER.
Fire Fighting Procedures:WEAR A SELF-CONTAINED BREATHING APPARATUS IN
POSITIVE PRESSURE MODE & FULL PROTECTIVE GEAR.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T STORE NEAR HEAT SOURCES, SPARKS,
OR FLAME.
Other Precautions:DON'T INGEST. KEEP AWAY FROM CHILDREN.
============= Exposure Controls/Personal Protection =============
Work Hygienic Practices:WASH SKIN & HANDS AFTER USE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Solubility in Water:INSOLUBLE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HEAT SOURCES, SPARKS, & FLAME.
Hazardous Decomposition Products:CO & CO2.
==================== Disposal Considerations ====================
Waste Disposal Methods:LANDFILL IN ACCORDANCE W/LOCAL, STATE, & FEDERAL
REGULATIONS.
| 1 | gloves_mandatory |
=======================================================
Product ID: 84-9802-0789-2 00-51111-43984-5, DISKETTE (SUPDAT)
Cage: EO130
=======================================================
Contractor Summary
=======================================================
Cage: 06XS2
Box: UNKNOW
Cage: EO130
=======================================================
Ingredients
=======================================================
Cas: 67-63-0
RTECS #: NT8050000
% Wt: 100
OSHA PEL: 400 PPM
ACGIH TLV: 400 PPM; 500 STEL
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: EYES: MOD EYE IRRIT: SIGNS/SYMPS CAN INCL REDNESS,
SWELLING, PAIN, TEARING & HAZY VISION. SKIN: MILD SKIN IRRIT: SIGNS/SYMPS
CAN INCL REDNESS, SWELLING & ITCHING. INHAL: CNS DEPRESS: SIGNS/SYMPS CAN
I NCL HEADACHE, DIZZINESS, DROWSINESS, INCOORDINATION, SLOWED REACTION TIME,
SLURRED SPEECH, GIDDINESS & (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: HLTH HAZ: UNCON. IRRIT (UPPER
RESPIRATORY): SIGNS/SYMPS CAN INCL SORENESS OF NOSE & THROAT, COUGHING
& SNEEZING. INGEST: IRRIT OF GI TISSUES: SIGNS/SYMPS CAN INCL PAIN,
VOMITING, ABDOMINAL TENDERNESS, NAUSEA, BLOOD IN VOMITUS & BLOOD IN
FECES. CNS DEPRESS: SIGNS/SYMPS CAN INCL HEADACHE, DIZZINESS, DROWSINESS,
MUSC WEAKNESS, INCOORD, SLOWED RXN TIME, FATIGUE, BLURRED VISION, SLURRED
SPEECH, GIDDINE SS, TREMORS & CONVULSIONS. ASPIR PNEUM: SIGNS/SYMPS CAN
INCLUDE COUGH, DFCLTY BRTHG, WHEEZING, COUGHING UP BLOOD & PNEUM WHICH
CAN BE FATAL.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: EYES: IMMED FLUSH EYES W/LARGE AMOUNTS OF WATER FOR AT LEAST 15
MINUTES. GET IMMED MED ATTN. SKIN: FLUSH SKIN W/LARGE AMOUNTS OF WATER. IF
IRRITATION PERSISTS, GET MED ATTN. INHAL: IF SIGNS/SYMPS OCCU R, REMOVE
PERSON TO FRESH AIR. IF SIGNS/SYMPS CONTINUE, CALL MD. INGEST: IF SWALLOWED,
CALL MD IMMED. ONLY INDUCE VOMITING AT INSTRUCTION OF MD. NEVER GIVE ANYTHING
BY MOUTH TO AN UNCONSCIOUS PERSON.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: REFER TO OTHER SECTIONS OF MSDS FOR INFO REGARDING
PHYSICAL & HEALTH HAZARDS, RESPIRATORY PROTECTION, VENTILATION &
PERSONAL PROTECTIVE EQUIPMENT. IN USA CALL 612-733-1110 OR 612-733-6100 FOR
24-HR SP ILL ASSISTANCE. EXTINGUISH ALL IGNITION SOURCES. COVER W/ABSORBENT
MATL. COLLECT SPILLED MATL. CLEAN UP RESIDUE. PLACE IN APPRVD METAL
CONTAINER.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL REGS
(FP N). INCINERATE IN AN INDUSTRIAL OR COMMERCIAL FACILITY. DISPOSE OF WASTE
PRODUCT IN A FACILITY PERMITTED TO ACCEPT CHEMICAL WASTE. MATL TO BE DIS
POSED HAS A US EPA HAZ NUMBER D001 (IGNITABLE).
Handling And Storage Precautions: FLAMMABLE LIQUID AND VAPOR. KEEP AWAY FROM
HEAT, SPARKS, OPEN FLAME AND OTHER SOURCES OF IGNITION.
Other Precautions: AVOID EYE CONTACT. AVOID SKIN CONTACT. DO NOT INGEST. KEEP
OUT OF THE REACH OF CHILDREN.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: 53.0F,11.7C
Lower Limits: 2.00%
Upper Limits: 12.00%
Extinguishing Media: CARBON DIOXIDE, FOAM, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA AND FULL PROTECTIVE EQUIPMENT
(FP N).
Unusual Fire/Explosion Hazard: NONE.
=======================================================
Control Measures
=======================================================
Respiratory Protection: AVOID BREATHING OF VAPORS.USE NIOSH APPROVED RESPIRATOR
APPROPRIATE FOR EXPOSURE OF CONCERN (FP N).
Ventilation: USE IN A WELL-VENTILATED AREA.
Other Protective Equipment: ANSI APPROVED EYE WASH & DELUGE SHOWER (FP N).
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: MFR'S TRADE NAME/PART NO: HEAD CLEANING KIT
(FLUIDS AND PACKETS).
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: 130F,54C
Vapor Pres: 33
Vapor Density: 5.0
Spec Gravity: 0.600 (H*2O=1)
VOC Grams/Liter: 785
Evaporation Rate & Reference: 0.80 (H*2O=1)
Solubility in Water: 100 G/100 CC
Appearance and Odor: CLEAR LIQUID; ALCOHOL ODOR.
Percent Volatiles by Volume: 100
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: HEAT.
Materials To Avoid: NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products: CARBON MONOXIDE AND CARBON DIOXIDE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: 84-9802-0789-2 00-51111-43984-5, DISKETTE (SUPDAT)
Cage: EO130
Assigned IND: Y
Company Name: IMATION ENTERPRISES CORPORATION
Street: 1 IMATION PLACE
Zipcode: 55128-1110
Label Required IND: Y
Date Of Label Review: 01/13/1997
Status Code: C
Label Date: 01/13/1997
Origination Code: G
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: Severe
Reactivity Hazard: None
Hazard And Precautions: EXTREMELY FLAMMABLE. ACUTE: EYES: MODERATE EYE
IRRITATION WITH REDNESS, SWELLING, PAIN, TEARING AND HAZY VISION. SKIN: MILD
SKIN IRRITATION WITH REDNESS, SWELLING AND ITCHING. INHALATION: CNS DEPRESSI
ON WITH HEADACHE, DIZZINESS, DROWSINESS, INCOORDINATION, SLOWED REACTION
TIME, SLURRED SPEECH, GIDDINESS AND UNCONSCIOUSNESS. IRRITATION. INGESTION:
IRRITATION OF GI TISSUE, CNS DEPRESSION, ASPIRATION PNEUMONITIS. CHRONIC:
NONE LISTED BY MANUFACTURER.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:23831087 9548 HYDROCHLORIC ACID 33-40%
CAGE:70829
CAGE:1K925
CAGE:70829
============= Composition/Information on Ingredients =============
Ingred Name:HYDROGEN CHLORIDE
CAS:7647-01-0
RTECS #:MW4025000
Minumum % Wt:33.
Maxumum % Wt:40.
OSHA PEL:C7 MG/M3;C5 PPM
ACGIH STEL:C7.5 MG/M3;C5 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Minumum % Wt:60.
Maxumum % Wt:67.
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(RABBIT): 900 MG/KG(SEE SUPP)
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CORROSIVE. INHALATION: INFLAMMATION OF
THE NOSE, THROAT & UPPER RESPIRATORY TRACT, PULMONARY EDEMA,
CIRCULATORY FAILURE & DEATH. INGESTION: BURNS OF THE MOUTH, THROAT,
ESOPHAGUS & GASTROINTESTINAL TRA CT. MAY BE FATAL IF SWALLOWED.
SKIN: SEVERE BURNS, LIQUID MAY CAUSE DEEP ULCERS & DISCOLORING OF
THE SKIN. EYES: IRRITATING, MAY CAUSE DAMAGE. SEVERE BURNS &
PERMANENT DAMAGE. LONG TERM EXPOSURE TO VA PORS MAY CAUSE EROSION
TO TEETH.
Explanation of Carcinogenicity:HYDROGEN CHLORIDE IS IARC CATEGORY 3
Effects of Overexposure:COUGHING, CHOKING, INFLAMMATION, PAIN, BURNS,
NAUSEA, VOMITING, DIARRHEA, REDNESS, TEETH EROSION.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN DISORDERS/EYE
DISEASE.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. GIVE CPR/OXYGEN IF
NECESSARY. INGESTION: DON'T INDUCE VOMITING. GIVE LARGE QUANTITIES
OF WATER/MILK. NEVER GIVE ANYTHING BY MOUTH IF UNCONSCIOUS. SKIN:
IMMEDIATELY FLU SH W/PLENTY OF WATER FOR 15 MINS. EYES: IMMEDIATELY
FLUSH W/PLENTY OF WATER FOR 15 MINS LIFTING LOWER & UPPER EYELIDS
OCCASIONALLY. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE WATER SPRAY. NEUTRALIZE W/SODA ASH/SLAKED LIME.
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING & NIOSH APPROVED
SELF CONTAINED BREATHING APPARATUS W/FULL FACEPIECE OPERATED IN THE
PRESSURE DEMAND/OTHER POSITIVE PRESSURE MODE. STAY AWAY FROM ENDS
OF TANKS. COOL TANK S W/WATER SPRAY UNTIL WELL AFTER FIRE IS OUT.
Unusual Fire/Explosion Hazard:EXTEME HEAT/CONTACT W/METALS CAN RELEASE
FLAMMABLE HYDROGEN GAS.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. WEAR PROTECTIVE EQUIPMENT.
ISOLATE AREA. KEEP UNNECESSARY/UNPROTECTED PERSONNEL FROM ENTERING.
CONTAIN & RECOVER LIQUID WHEN POSSIBLE. NEUTRALIZE & ABSORB W/INERT
MATERIAL; VERMICULITE , DRY SAND/EARTH & PLACE IN A CHEMICAL WASTE
CONTAINER. DON'T USE COMBUSTIBLE MATERIALS, SAWDUST. DON'T FLUSH TO
SEWER.
Neutralizing Agent:ALKALINE MATERIAL; SODA ASH, LIME.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY, VENTILATED
STORAGE AREA W/ACID RESISTANT FLOORS & GOOD DRAINAGE. PROTECT FROM
PHYSICAL DAMAGE. KEEP OUT OF DIRECT SUNLIGHT & AWAY FROM HEAT,
WATER & INCOMPATIBLE MATERIALS. DON'T WASH OUT CONTAINER & USE IT
FOR OTHER PURPOSES. USE ONLY W/ADEQUATE VENTILATION.
Other Precautions:WHEN DILUTING, THE ACID SHOULD ALWAYS BE ADDED SLOWLY
TO WATER & IN SMALL AMOUNTS. NEVER USE HOT WATER & NEVER ADD WATER
TO THE ACID. WATER ADDED TO ACID CAN CAUSE UNCONTROLLED BOILING &
SPLASHING. WH EN OPENING METAL CONTAINERS, USE NON-SPARKING TOOLS
BECAUSE OF THE POSSIBILITY OF HYDROGEN GAS BEING PRESENT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF THE EXPOSURE LIMIT IS EXCEEDED, A FULL
FACEPIECE RESPIRATOR W/AN ACID GAS CARTRIDGE MAY BE WORN UP TO 50
TIMES THE EXPOSURE LIMIT/THE MAXIUMUM USE CONCENTRATION SPECIFIED
BY THE APPROPRIATE REGULAT ORY AGENCY/RESPIRATOR SUPPLIER. FOR
EMERGENCIES/INSTANCES WHERE THE EXPOSURE LEVELS ARE UNKNOWN, USE A
FULL FACEPIECE POSITIVE PRESSURE AIR SUPPLIED RESPIRATOR.
Ventilation:LOCAL/GENERAL EXHAUST IS RECOMMENDED TO KEEP AIRBORNE
EXPOSURES BELOW THE AIRBORNE.
Other Protective Equipment:IMPERVIOUS BOOTS, APRON, COVERALLS, EYE WASH
FOUNTAIN, QUICK DRENCH FACILITIES IN THE WORK AREA.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING & SHOES
BEFORE REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
CONTAINERS OF THIS MATERIAL MAY BE HAZARDOUS WHEN EMPTY SINCE THEY
RETAIN PRODUCT RESIDUES/VAPORS/LIQUID. OBSERVE ALL WARNINGS &
PRECAUTIONS LISTED FOR THE PRODUCT. DON'T GET IN EYES, ON SKIN/ON
CLOTH ING. DON'T BREATHE VAPOR/MIST.
================== Physical/Chemical Properties ==================
Boiling Pt:=108.9C, 228.F
Melt/Freeze Pt:=-74.C, -101.2F
Vapor Pres:190
pH:0.1
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS, FUMING LIQUID
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER, STRONG BASES, METALS, METAL OXIDES, HYDROXIDES, AMINES,
CARBONATES, ALKALINE MATERIALS, CYANIDES, SULFIDES, SULFITES,
FORMADEHYDE
Stability Condition to Avoid:HEAT, DIRECT SUNLIGHT
Hazardous Decomposition Products:HYDROGEN CHLORIDE FUMES, CHLORINE
FUMES, HYDROGEN GAS
=================== Toxicological Information===================
Toxicological Information:HYDROCHLORIC ACID CONCENTRATED: INVESTIGATED
AS A TUMORIGEN, MUTAGEN, REPRODUCTIVE EFFECTOR.
===================== Ecological Information =====================
Ecological:WHEN RELEASED INTO THE SOIL, THIS MATEIAL IS NOT EXPECTED TO
BIODEGRADE. WHEN RELEASED INTO THE SOIL, THIS MATERIAL MAY LEACH
INTO GROUNDWATER. THIS MATERIAL IS EXPECTED TO BE TOXIC TO AQUATIC
LIFE.
==================== Disposal Considerations ====================
Waste Disposal Methods:WHATEVER CAN NOT BE SAVED FOR RECOVERY/RECYCLING
SHOULD BE HANDLED AS HAZARDOUS WASTE & SENT TO A RCRA APPROVED
WASTE FACILITY. DISPOSE OF CONTAINER & UNUSED CONTENTS IN
ACCORDANCE W/FEDERAL, STATE & LOCAL REQUIREMENTS.
=================== MSDS Transport Information ===================
Transport Information:HYDROCHLORIC ACID; UN1789.
===================== Regulatory Information =====================
SARA Title III Information:SARA 311/312: ACUTE=YES, CHRONIC=YES/ SARA
302/313: HYDROGEN CHLORIDE
Federal Regulatory Information:CDTA & TSCA: HYDROGEN CHLORIDE
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:AEROSHELL GREASE 6 (MIL-G-24139A)
Resp. Party Other MSDS Num.:56100E-07
Preparer's Name:KAREN G. HAYNES
CAGE:3N254
CAGE:1J6U8
CAGE:3N254
CAGE:0T5C6
CAGE:0PGK2
============= Composition/Information on Ingredients =============
Ingred Name:HYDROTREATED HEAVY PARAFFINIC DISTILLATE (PETROLEUM)
CAS:64742-54-7
RTECS #:PY8035500
Minumum % Wt:85.
Maxumum % Wt:90.
Ingred Name:INORGANIC CLAY
CAS:1302-78-9
RTECS #:CT9450000
Minumum % Wt:5.
Maxumum % Wt:10.
Ingred Name:FATTY ACID AMIDES
CAS:68910-93-0
Minumum % Wt:3.
Maxumum % Wt:5.
Ingred Name:ADDITIVES
Minumum % Wt:3.
Maxumum % Wt:5.
===================== Hazards Identification =====================
LD50 LC50 Mixture:NOT PROVIDED BY MANUFACTURER
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE-MAY BE MILDLY IRRITATING TO THE
EYES. SKIN-PROLONGED OR REPEATED CONTACT MAY CAUSE VARIOUS SKIN
DISORDERS SUCH AS DERMATITIS, FOLLICULITIS OR OIL ACNE. RELEASE
DURING HIGH PRESSURE USAGE MAY RESUL T IN INJECTION OF GREASE INTO
THE SKIN CAUSING LOCAL NECROSIS. INHALATION-NOT EXPECTED TO BE A
RELEVANT ROUTE OF EXPOSURE, HOWEVER, UNDER HIGH TEMPERATURE
CONDITIONS, VAPORS IRRITATING TO THE NOSE, TH ROAT AND UPPER
RESPIRATORY TRACT MAY BE PRODUCED. INGESTION-LUBRICATING GREASES
ARE GENERALLY CONSIDERED NO MORE THAN SLIGHTLY TOXIC IF SWALLOWED.
Explanation of Carcinogenicity:THIS PRODUCT AND ITS COMPONENTS ARE NOT
CLASSIFIED AS CARCINOGENS BY IARC, NTP, OR OSHA.
Effects of Overexposure:EYE-MAY BE MILDLY IRRITATING TO THE
EYES.SKIN-PROLONGED OR REPEATED CONTACT MAY CAUSE VARIOUS SKIN
DISORDERS SUCH AS DERMATITIS, FOLLICULITIS OR OIL ACNE.RELEASE
DURING HIGH PRESSURE USAGE MAY RESULT IN INJECTION OF GREASE INTO
THE SKIN CAUSING LOCAL NECROSIS. INHALATION-NOT EXPECTED TO BE A
RELEVANT ROUTE OF EXPOSURE, HOWEVER,UNDER HIGH TEMPERATURE
CONDITIONS, VAPORS IRRITATING TO THE NOSE, THROA T & UPPER
RESPIRATORY TRACT MAY BE PRODUCED.INGESTION-LUBRICATING GREASES ARE
GENERALLY CONSIDERED NO MORE THAN SLIGHTLY TOXIC IF SWALLOWED.LOCAL
NECROSIS IS EVIDENCED BY DELAYED ONSET OF PAIN & TISSU E DAMAGE A
FEW HOURS FOLLOWING INJECTION
Medical Cond Aggravated by Exposure:PREEXISTING SKIN DISORDERS MAY BE
AGGRAVATED BY EXPOSURE TO THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:EYE-FLUSH WITH WATER FOR 15 MINUTES. HOLD EYELIDS OPEN. GET
MEDICAL ATTENTION. SKIN-REMOVE CONTAMINATED CLOTHING. WIPE EXCESS
OFF. WASH WITH SOAP AND WATER OR WATERLESS HAND CLEANER FOLLOWED
BY SOAP AND WATER. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE. IF
IRRITATION PERSIST, GET MEDICAL ATTENTION. IF MATERIAL INJECTED
UNDER SKIN, GET MEDICAL ATTENTION PROMPTLY; DO NOT WAIT FOR
SYMPTOMS TO DEVELO P. INHALATION-MOVE FRESH AIR. GIVE OXYGEN IF
BREATHING DIFFICULT. GET MEDICAL ATTENTION. INGESTION-DO NOT INDUCE
VOMITING. IN GENERAL, NO TREATMENT IS NECESSARY UNLESS LARGE
AMOUNTS ARE INGESTED. GET MEDICAL ADVICE.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:=198.9C, 390.F
BASE OIL
Extinguishing Media:USE WATER FOG, DRY CHEMICAL OR CO2. DO NOT USE A
DIRECT STREAM OF WATER. PRODUCT WILL FLOAT AND CAN BE REIGNITED ON
SURFACE OF WATER.
Fire Fighting Procedures:DO NOT ENTER CONFINED FIRE SPACE WITHOUT
PROPER PROTECTIVE EQUIPMENT INCLUDING A NIOSH APPROVED
SELF-CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED CONTAINER
SURROUNDING EQUIPMENT AND STRUCTURES WIT H WATER.
Unusual Fire/Explosion Hazard:NONE IDENTIFIED.
================== Accidental Release Measures ==================
Spill Release Procedures:SCOOP UP EXCESS GREASE. CLEAN AREA WITH
APPROPRIATE CLEANER.
Neutralizing Agent:NOT PROVIDED BY MANUFACTURER
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE WITH
ADEQUATE VENTILATION. KEEP AWAY FROM OPEN FLAMES AND HIGH
TEMPERATURES.
Other Precautions:MINIMIZE SKIN CONTACT. WASH WITH SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES.
LAUNDER CONTAMINATED CLOTHING BEFORE REUSE. PROPERLY DISPOSE OF
CONTAMINATED LEATHER ARTICL ES, INCLUDING SHOES, THAT CANNOT BE
DECONTAMINATED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT ORDINARILY REQUIRED.
Ventilation:NOT PROVIDED BY MANUFACTURER
Other Protective Equipment:USE OTHER CLOTHING AS NEEDED TO MINIMIZE
SKIN CONTACT.
Work Hygienic Practices:NOT PROVIDED BY MANUFACTURER
Supplemental Safety and Health
SHELL CODE: 70026. NOTE TO PHYSICIAN: IN GENERAL, EMESIS INDUCTION IS
UNNECESSARY IN HIGH VISCOSITY, LOW VOLATILITY PRODUCTS, I.E., MOST
OILS AND GREASES.
================== Physical/Chemical Properties ==================
HCC:V6
Boiling Pt:B.P. Text:NOT AVAILABLE
Melt/Freeze Pt:=148.9C, 300.F
M.P/F.P Text:DROP POINT
Vapor Pres:<0.1
Spec Gravity:NOT AVAILABLE
Evaporation Rate & Reference:NOT AVAILABLE
Solubility in Water:INSOLUBLE
Appearance and Odor:DARK AMBER, SMOOTH SOLID; SLIGHT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CONTACT WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:AVOID HEAT, OPEN FLAME.
Hazardous Decomposition Products:A COMPLEX MIXTURE OF AIRBORNE SOLID,
LIQUID PARTICULATES & GASES WILL EVOLVE WHEN THIS MATERIAL
UNDERGOES PYROLYSIS OR COMBUSTION. CARBON MONOXIDE & UNIDENTIFIED
ORGANIC COMPOUNDS MAY BE FORMED.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
=================== Toxicological Information===================
Toxicological Information:NOT PROVIDED BY MANUFACTURER
===================== Ecological Information =====================
Ecological:THIS PRODUCT IS COVERED BY EPA`S COMPREHENSIVE ENVIRONMENTAL
RESPONSE,COMPENSATION AND LIABILITY ACT (CERCLA) PETROLEUM
EXCLUSION. THEREFORE, RELEASES TO AIR, LAND OR WATER ARE NOT
REPORTABLE UND ERCERCLA ("SUPERFUND"). HOWEVER, UNDER SECTION
311 OF EPA`S CLEAN WATER ACT (CWA), THIS PRODUCT IS CONSIDERED AN
OIL. AS SUCH, SPILLS INTO OR LEADING TO SURFACE WATERS THAT CAUSE
A SHEEN MUST B E REPORTED TO THE NATIONAL RESPONSE CENTER,
800-424-8802.
==================== Disposal Considerations ====================
Waste Disposal Methods:IF THIS PRODUCT BECOMES A WASTE, IT WOULD NOT BE
A HAZARDOUS WASTE BY RCRA CRITERIA (40 CFR 261). PLACE IN AN
APPROPRIATE DISPOSAL FACILITY IN COMPLIANCE WITH LOCAL REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:NOT HAZARDOUS BY D.O.T. REGULATIONS. DOT PROPER
SHIPPING NAME: NOT APPLICABLE.
===================== Regulatory Information =====================
SARA Title III Information:BASED ON THE DATA AVAILABLE, THE PRODUCT IS
NOT REGULATED UNDER SARA TITLE III.
Federal Regulatory Information:THE COMPONENTS OF THIS PRODUCT ARE
LISTED ON THE EPA/TSCA INVENTORY OF CHEMICAL SUBSTANCES.
PROTECTION OF ATMOSPHERIC OZONE (PURSUANT TO SECTION 611 OF THE
CLEAN AIR ACT AMENDMENTS OF 1990): PER 40 C FR PART 82, THIS
PRODUCT DOES NOT CONTAIN NOR WAS IT DIRECTLY MANUFACTURED WITH ANY
CLASS I OR CLASS II OZONE DEPLETING SUBSTANCES.
State Regulatory Information:BASED ON INFORMATION AVAILABLE, THIS
PRODUCT DOES NOT CONTAIN ANY CHEMICAL SUBSTANCE LISTED ON A
CHEMICAL SPECIFIC STATE LIST.
======================= Other Information =======================
| 1 | gloves_mandatory |
Subsets and Splits
No community queries yet
The top public SQL queries from the community will appear here once available.