text
stringlengths 542
18.7k
| label
int64 0
1
| label_text
stringclasses 2
values |
|---|---|---|
===================== Product Identification =====================
Product ID:U-24 LATEX
CAGE:4Z694
CAGE:4Z694
============= Composition/Information on Ingredients =============
Ingred Name:ACRYLIC POLYMER
CAS:25608-63-7
Fraction by Wt: 36%
Ingred Name:DEFOAMER
Fraction by Wt: 0.5%
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 63%
Ingred Name:RESIDUAL MONOMER
Fraction by Wt: TRACE
Ingred Name:FORMALDEHYDE (SARA III)
CAS:50-00-0
RTECS #:LP8925000
Fraction by Wt: 0.05%
OSHA PEL:1 PPM; 2 PPM STEL
ACGIH TLV:1 PPM; 2 PPM STEL
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(ORAL RAT) >50 G/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:INHAL: PROLONGED CONTACT TO VAPOR/MIST
CAN CAUSE HEADACHES, NAUSEA & IRRITATION OF NOSE, THROAT & LUNGS.
SKIN: IRRITATION OF SKIN UPON REPEATED OR PROLONGED CONTACT. EYES:
CONTACT SLIGHTLY IRRITATING TO EYES.
Explanation of Carcinogenicity:FORMALDEHYDE: GRP 2A (IARC
VOL7,P211,'87); ANTIC TO BE CARCIN (NTP 6TH ANN RPT, '91); OSHA
(SUPDAT)
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:MOVE SUBJECT TO FRESH AIR. EYES:FLUSH W/A LARGE AMOUNT
OF WATER FOR AT LEAST 15 MINS. SEE MD IF IRRITATION PERSISTS.
SKIN:WASH AFFECTED SKIN AREAS W/SOAP & WATER. INGEST:CALL MD
IMMEDIATELY (FP N).
===================== Fire Fighting Measures =====================
Flash Point:NON-COMBUSTIBLE
Extinguishing Media:USE MEDIA SUITABLE FOR SURROUNDING FIRE CONDITIONS
.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:MATERIAL CAN SPLATTER ABOVE 212F. POLYMER
FILMS CAN BURN.
================== Accidental Release Measures ==================
Spill Release Procedures:KEEP SPECTATORS AWAY. FLOOR MAY BE SLIPPERY;
USE CARE TO AVOID FALLING. DIKE & CONTAIN SPILL W/INERT MATL (E.G.
SAND OR EARTH). TRANSFER LIQ TO CONTRS FOR RECOVERY OR DISP & SOLID
DIKING MATL TO SEPAR ATE CONTRS FOR DISP. KEEP SPILLS & (SUPP DATA)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STOR TEMP 140F MAX & 34F MIN. KEEP
AWAY FROM FREEZING; PROD MAY COAGULATE. MAINTAIN ADEQ VENT WHERE
PROD IS HEATED OR CURED.
Other Precautions:MONOMER VAPORS CAN BE GENERATED WHEN PRODUCT IS
HEATED DURING PROCESSING OPERATIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED IF GOOD VENTILATION IS MAINTAINED.
WEAR NIOSH/MSHA APPROVED OR EQUIVALENT RESPIRATOR SUITABLE FOR
CONCENTRATIONS & TYPES OF AIR CONTAMINANTS ENCOUNTERED.
Ventilation:LOCAL EXHAUST VENTILATION AT POINT OF CONTAMINATION.
MECHANICAL VENTILATION AT POINT OF CONTAMINATION ENCOUNTERED.
Other Protective Equipment:ADEQUATE SKIN PROTECTION.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
SPILL PROC:CLEANING RUNOFFS OUT OF MUNICIPAL SEWERS & OPEN BODIES OF
WATER. CARCIN COMMENTS: REGULATED CARCINOGEN, 29 CFR 1910.1048,
1JUL92 .
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:17 @ 20C
Vapor Density:< WATER
Spec Gravity:1-1.2 (H*2O=1)
pH:9.5-10
Evaporation Rate & Reference:LESS THAN WATER
Solubility in Water:DILUTABLE
Appearance and Odor:MILKY WHITE LIQUID; MILD ACRYLIC ODOR.
Percent Volatiles by Volume:52-54
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:TEMPERATURES OVER 350F.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:COAGULATE THE EMULSION BY THE STEPWISE ADDITION
OF FERRIC CHLORIDE & LIME. REMOVE THE CLEAR SUPERNANT LIQUID &
FLUSH TO CHEMICAL SEWER. LANDFILL OR INCINERATE SOLID & CONTAMD
DIKING MATERIAL ACCORDING TO LOCAL, STATE & FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:DOW CORNING 510 FLUID, 50 CS
Resp. Party Other MSDS Num.:02334046
Preparer's Name:DOW CORNING CORPORATION
CAGE:5D028
Contract Num:SP0450-01-M-LK24
CAGE:1MDA6
CAGE:5D028
============= Composition/Information on Ingredients =============
Ingred Name:PHENYLHEPTAMETHYL CYCLOTETRASILOXANE
CAS:10448-09-6
RTECS #:GZ4392000
< Wt:.1
Ingred Name:2,6-CIS-DIPHENYLHEXAMETHYL CYCLOTETRASILOXANE
CAS:33204-76-1
RTECS #:GZ4390000
< Wt:.1
===================== Hazards Identification =====================
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE EFFECTS - EYE: DIRECT CONTACT
MAY CAUSE TEMPORARY REDNESS AND DISCOMFORT. SKIN: NO SIGNIFICANT
IRRITATION EXPECTED FROM A SINGLE SHORT-TERM EXPOSURE. INHALATION:
NO SIGNIFICANT EFFECT EXPECTED F ROM A SINGLE SHORT-TERM EXPOSURE.
ORAL: LOW INGESTION HAZARD IN NORMAL USE. PROLONGED/REPEATED
EXPOSURE EFFECTS: SKIN: NO KNOWN APPLICABLE INFORMATION.
INHALATION: NO KNOWN APPLICABLE INFORMATION. OR AL: NO KNOWN
APPLICABLE INFORMATION.
Effects of Overexposure:NO KNOWN APPLICABLE INFORMATION.
Medical Cond Aggravated by Exposure:NO KNOWN APPLICABLE INFORMATION.
======================= First Aid Measures =======================
First Aid:EYE: IMMEDIATELY FLUSH WITH WATER. SKIN: NO FIRST AID SHOULD
BE NEEDED. INHALATION: NO FIRST AID SHOULD BE NEEDED. ORAL: NO
FIRST AID SHOULD BE NEEDED. COMMENTS: TREAT SYMPTOMATICALLY.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:>101.1C, 214.F
Autoignition Temp:Autoignition Temp Text:N/D
Extinguishing Media:ON LARGE FIRES USE DRY CHEMICAL, FOAM OR WATER
SPRAY. ON SMALL FIRES USE CARBON DIOXIDE(CO2), DRY CHEMICAL OR
WATER SPRAY. WATER CAN BE USED TO COOL FIRE EXPOSED CONTAINERS.
Fire Fighting Procedures:SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING SHOULD BE WORN IN FIGHTING LARGE FIRES
INVOLVING CHEMICALS. USE WATER SPRAY TO KEEP FIRE EXPOSED
CONTAINERS COOL. DETERMINE THE NEED TO EVACU ATE OR ISOLAE THE AREA
ACCORDING TO YOUR LOCAL EMERGENCY PLAN.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:DETERMINE WHETHER TO EVACUATE OR ISOLATE THE
AREA ACCORDING TO OUR LOCAL EMERGENCY PLAN. OBSERVE ALL PERSONAL
PROTECTION EQUIPMENT RECOMMENDATIONS. FOR LARGE SPILLS, PROVIDE
DIKING OR OTHER APPROPRIAT E CONTAINMENT. IF DIKED MATERIAL CAN BE
PUMPED, STORE RECOVERED MATERIAL IN APPROPRIATE CONTAINER. CLEAN UP
REMAINING MATERIAL FROM SPILL WITH SUITABLE ABSORBANT. (SEE OTHER
INFORMATION)
======================Handling and Storage ======================
Handling and Storage Precautions:USE WITH ADEQUATE VENTILATION. USE AT
HIGH TEMPERATURES MAY EVOLVE OR GENERATE
PHENYLHEPTAMETHYLCYCLOTETRASILOXANE,
2,6-CIS-DIPHENYLHEXAMETHYLCYCLOTETRASILOXANE. PROVIDE ADEQUATE
VENTILATION TO CONTRO L WITHIN EXPOSURE GUIDELINES.
Other Precautions:PERSONNEL SHOULD WEAR ORGANIC VAPOR RESPIRATORS UNTIL
WORKPLACE EXPOSURE LEVELS HAVE BEEN DETERMINED. TRACES OF BENZENE
(CARCINOGEN) MAY FORM IF HEATED IN AIR ABOVE 300F (149C). PROVIDE
VENTILATION TO CONTROL VAPOR EXPOSURE WITHIN INHALATION GUIDELINES
WHEN HANDLING AT ELEVATED TEMPERATURES. REVIEW THE OSHA BENZENE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NO RESPIRATORY PROTECTION SHOULD BE NEEDED.
Ventilation:LOCAL VENTILATION: NONE SHOULD BE NEEDED. GENERAL
VENTILATION: RECOMMENDED.
Work Hygienic Practices:WASHING AT MEALTIME AND END OF SHIFT IS
ADEQUATE. AVOID EYE CONTACT. USE REASONABLE CARE.
Supplemental Safety and Health
NOTE: THESE PRECAUTIONS ARE FOR ROOM TEMPERATURE HANDLING. USE AT
ELEVATED TEMPERATURE OR AEROSOL/SPRAY APPLICATIONS MAY REQUIRE
ADDED PRECAUTIONS.
================== Physical/Chemical Properties ==================
Boiling Pt:>35.C, 95.F
Melt/Freeze Pt:M.P/F.P Text:N/D
Vapor Pres:NOT DETERMINED
Spec Gravity:@ 25C: 0.988
Viscosity:50 CST
Solubility in Water:NOT DETERMINED
Appearance and Odor:COLORLESS LIQUID; ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIAL CAN CAUSE A REACTION.
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:SILICON DIOXIDE. CARBON OXIDES AND
TRACES OF INCOMPLETELY BURNED CARBON COMPOUNDS. FORMALDEHYDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
=================== Toxicological Information===================
Toxicological Information:THIS COMPOUND MAY CONTAIN LOW LEVELS OF
PHENYLHEPTAMETHYLCYCLOTETRASILOXANE AND
2,6-CIS-DIPHENYLHEXAMETHYLCYCLOTETRASILOXANE WHICH ARE
ESTROGEN-LIKE CHEMICALS. ESTROGENS ARE HORMONE SUBSTANCES WHICH A
FFECT THE REPRODUCTIVE SYSTEM.
===================== Ecological Information =====================
Ecological:ACUTE AQUATIC TOXICITY (MG/L) HIGH <=1, MEDIUM >1 AND <=100,
& LOW >100. ACUTE TERRESTRIAL TOXICITY HIGH <=100, MEDIUM >100 AND
<=2000, & LOW >2000.
==================== Disposal Considerations ====================
Waste Disposal Methods:STATE OR LOCAL LAWS MAY IMPOSE ADDITIONAL
REGULATORY REQUIREMENTS REGARDING DISPOSAL. CALL DOW CORNING
CORPORATE ENVIRONMENTAL MANAGEMENT, (517) 496-6315, IF ADDITIONAL
INFORMATION IS REQUIRED.
=================== MSDS Transport Information ===================
Transport Information:NOT SUBJECT TO DOT.
===================== Regulatory Information =====================
SARA Title III Information:SECTION 312 HAZARD CLASS: CHRONIC. SECTION
313 TOXIC CHEMICALS: NONE PRESENT OR NONE PRESENT IN REGULATED
QUANTITIES.
Federal Regulatory Information:TSCA STATUS: ALL CHEMICAL SUBSTANCES IN
THIS MATERIAL ARE INCLUDED ON OR EXEMPTED FROM LISTING ON THE TSCA
INVENTORY OF CHEMICAL SUBSTANCES.
State Regulatory Information:WARNING: THIS PRODUCT CONTAINS THE
FOLLOWING CHEMICAL(S) LISTED BY THE STATE OF CALIFORNIA UNDER THE
SAFE DRINKING WATER AND TOXIC ENFORCEMENT ACT OF 1986 (PROPOSITION
65) AS BEING KNOWN TO CAUSE CANC ER, BIRTH DEFECTS OR OTHER
REPRODUCTIVE HARM.NEW JERSEY: CAS# 63148-52-7, >60.0, DIMETHYL,
PHENYLMETHYL SILOXANE, TRIMETHYL-TERMINATED; CAS# 63148-62-9,
1.0-5.0, POLYDIMETHYLSILOXANE. PENNSYLVANIA: CAS# 63148-52-7,
>60.0, DIMETHYL, PHENYLMETHYL SILOXANE, TRIMETHYL-TERMINATED.
MASSACHUSETTS: NONE .
======================= Other Information =======================
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:HEXANES PLUS MIXTURE
CAGE:NO394
CAGE:0WK23
CAGE:NO394
============= Composition/Information on Ingredients =============
Ingred Name:HEXANE (N-HEXANE); (C6)
CAS:110-54-3
RTECS #:MN9275000
OSHA PEL:50 PPM
ACGIH TLV:50 PPM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:HEPTANE; (N-HEPTANE) (C7)
CAS:142-82-5
RTECS #:MI7700000
OSHA PEL:400 PPM;500 STEL
ACGIH TLV:400 PPM;500 STEL
Ingred Name:OCTANE; (C8)
CAS:111-65-9
RTECS #:RG8400000
OSHA PEL:300 PPM;375 STEL
ACGIH TLV:300 PPM;375 STEL
Ingred Name:NONANE; (C9)
CAS:111-84-2
RTECS #:RA6115000
OSHA PEL:200 PPM
ACGIH TLV:200 PPM
Ingred Name:DECANE; (C10)
CAS:124-18-5
RTECS #:HD6550000
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT) IS 28,710 MG/KG HEXANE
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN AND MUCOUS MEMBRANE EXPOSURE IS
AS A SIMPLE IRRITANT. INHALATION EFFECTS ARE SIMILIAR TO THAT OF A
SIMPLE ASPHYXIANT. NO LONG TERM EFFECTS ARE KNOWN OF BREATHING
SMALL QUANTITIES OF THESE VAPORS. INGESTION EFFECTS ARE NOT FULLY
UNDERSTOOD.
Explanation of Carcinogenicity:NOT LISTED AS CARCINOGEN OR POTENTIAL
CARCINOGEN.
Effects of Overexposure:EXPOSURE TO THE SKIN SHOULD CAUSE IRRITATION,
REDNESS AND POSSIBLE RASH. INHALATION EFFECTS SHOULD INCLUDE
COUGHING, CHEST PAINS, AND EDEMA WHICH COULD BE FATAL. INGESTION
EFFECTS ARE GASTROINTESTINAL DISTURBANCES, NAUSEA, HEADACHE AND
VOMITING.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION-CONSCIOUS PERSONS SHOULD BE ASSISTED TO AN
UNCONTAMINATED AREA & INHALE FRESH AIR. QUICKLY REMOVE. UNCONSCIOUS
PERSON SHOULD BE MOVED TO AN UNCONTAMINATED AREA, GIVEN
MOUTH-TO-MOUTH RESUSCI TATION & SUPPLEMENTAL OXYGEN. SKIN/EYE-FLUSH
EFFECTED ARE WITH PLENTY OF WATER FOR AT LEAST 15 MIN.
INGESTION-INDUCE VOMITING TO DIVEST VICTIM OF WHAT HAS BEEN
INGESTED.
===================== Fire Fighting Measures =====================
Flash Point:HEXANE=-7F,-22C
Lower Limits:0.78%
Upper Limits:7.7%
Extinguishing Media:WATER, DRY CHEMICAL, CARBON DIOXIDE.
Fire Fighting Procedures:IF POSSIBLE, STOP FLOW OF HYDROCARBON MIXTURE.
USE WATER SPRAY TO COOL SURROUNDING CONTAINERS.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE ALL PERSONNEL FROM AFFECTED AREA. USE
APPROPIATE PROTEXTIVE EQUIPMENT. IF LEAK IS IN USER'S EQUIPMENT, BE
CERTAIN TO PURGE PIPING W/AN INERT GAS PRIOR TO ATTEMPTING REPAIRS.
IF LEAK IS IN CON TAINER VALVE, CONTACT YOUR CLOSEST LIQUID AIR
LOC.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE ONLY IN WELL VENTILATED AREAS.
CLOSE VALVE AFTER EACH USE AND WHEN EMPTY.
Other Precautions:THIS MIX IS PREPARED IN A SPECIAL "PISTON" TYPE
CYLINDER WHICH IS DESIGNED TO ELIMINATE PROBLEMS WITH FRACTIONATION
CHANGING THE MIX AS CYLINDER EMPTIES. BE CERTAIN TO READ &
UNDERSTAND THE BROCHURE D ESCRIBING THE ALPHAGAZ PISTON CYLINDER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:POSITIVE PRESSURE AIR LINE WITH MASK OR SCBA
SHOULD BE AVAILABLE FOR EMERGENCY USE.
Ventilation:HOOD WITH FORCED VENTILATION. LOC: TO PVNT ACCUMULATION
ABOVE TWA. MECH (GEN): IN ACCORDANCE WITH ELECTRICAL CODES.
Other Protective Equipment:SAFETY SHOES, SAFETY SHOWER, EYEWASH
"FOUNTAIN".
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
STORE IN COOL, DRY, WELL-VENTILATED AREA OF NON-COMBUSTIBLE
CONSTRUCTION AWAY FROM HEAVILY TRAFFICKED AREAS AND EMERGENCY
EXITS.
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:155F,68C
Melt/Freeze Pt:M.P/F.P Text:-139F,-95C
Vapor Pres:4.96 PSIA
Vapor Density:0.2002
Solubility in Water:VERY SLIGHTLY
Appearance and Odor:COLORLESS LIQUID AND VAPOR WITH HYDROCARBON ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXYGEN, OTHER OXIDIZERS.
Hazardous Decomposition Products:NONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT ATTEMPT TO DISPOSE OF WASTE/UNUSED
QUANTITY. RETURN IN THE SHIPPING CONTAINER PROPERLY LABLED, W/ANY
VALVE OUTLET PLUGS OR CAPS SECURED & VALVE PROT CAP IN PLACE TO
YOUR SUPPLIER.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TURCO AVIATION, 05570
Preparer's Name:RD MCLAUGHLIN JR
CAGE:0BYL8
CAGE:02BJ0
CAGE:0BYL8
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM METASILICATE
CAS:6834-92-0
RTECS #:VV9275000
Fraction by Wt: 40-50%
OSHA PEL:15 MG/M3 (MFR)
ACGIH TLV:10 MG/M3 (MFR)
Ingred Name:SODIUM PHOSPHATE, DIBASIC (CERCLA)
CAS:7558-79-4
RTECS #:WC4500000
Fraction by Wt: 25-35%
OSHA PEL:15 MG/M3 (MFR)
ACGIH TLV:10 MG/M3 (MFR)
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TRIPHOSPHORIC ACID, PENTASODIUM SALT; (SODIUM PHOSPHATE,
TRIBASIC) (CERCLA)
CAS:7758-29-4
RTECS #:YK4570000
Fraction by Wt: 15-25%
OSHA PEL:15 MG/M3 (MFR)
ACGIH TLV:10 MG/M3 (MFR)
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:NONYL PHENOL POLYETHYLENE GLYCOL
CAS:26027-38-3
RTECS #:MD0906000
Fraction by Wt: <5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPDAT: LIMITATIONS SPECIFIED BY NIOSH/MFR. FOR EMER &
OTHER CNDTNS WHERE THERE IS POTNTL FOR SIGNIFICANT EXPOS (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5: USE NIOSH APPRVD FULL FACE POSTIVE-PRESSURE,
SCBA/POSITIVE PRESSURE AIRLINE W/AUXILIARY AIR SUPPLY. (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6: RESPIRATORY PROTECTION PROGRAMS MUST COMPLY WITH 29
CFR 1910.134.
RTECS #:9999999ZZ
Ingred Name:VENT: PROVIDE VENT IF NECESSARY TO MINIMIZE EXPOSURE. IF
PRACTICAL, USE LOC MECH EXHAUST VENT AT SOURCES OF (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8: AIR CONTAMINATION, SUCH AS OPEN PROCESS EQUIPMENT.
RTECS #:9999999ZZ
Ingred Name:EYE PROT: & FULL LENGTH FACESHIELD .
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYE: CORROSIVE. OVEREXP WILL
CAUSE EXTREME BURNS THAT MAY RSLT IN PERM DMG TO EYES. EXPOSURE TO
LOW LEVEL CONCS MAY CAUSE MOD IRRIT/CONJ. SKIN: CORROSIVE.
SOLIDS/DUST WILL CAUSE IRRIT, PRLNGD E XPOSURE WILL CAUSE
IRREVERSIBLE SCARRING. OTHER TOXIC EFTS: PROD DOES NOT CNTN ANY
COMPONENTS LISTED (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: BY IARC, NTP/OSHA AS CARCINS. TARGET
ORGAN TOXIN: INGESTION MAY CAUSE SEV BURNS OF MOUTH & THROAT.
PRLNGD EXPOS TO SKIN WILL CAUSE IRREVERSIBLE SCARRING. INHAL OF
DUSTS CAN CAUSE BURNS TO MU C MEMB. TOX COMMENTS: INDIVIDUALS
W/BRTHG DFCLTY MAY FIND EXPOS TO PROD INCR THAT DFCLTY. SUCH
INDIVIDUALS (SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST: DO NOT INDUCE VOMIT. GIVE PLENTY OF WATER. GET MED
ATTN. IF SWALLOWED, DO NOT INDUCE VOMIT. GIVE PLENTY OF WATER TO
DRINK, FOLLOWED BY MILK OF MAGNESIA. NEVER GIVE ANYTHING BY MOUTH
TO UNCON P ERSON. SKIN: WASH W/SOAP & WATER. GET MED ATTN. CONTAMD
CLTHG REMOVE & LAUNDER. EYE CONT: FLUSH W/PLENTY OF WATER FOR @ LST
15 MINS. GET MED ATTN. IF IN EYES, IMMED FLUSH W/PLENTY OF WATER,
(SUPDAT)
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER SPRAY, WATER FOG, WATER STREAM.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . COOL FIRE EXPOSED CONTAINERS WITH WATER.
Unusual Fire/Explosion Hazard:NOT APPLICABLE.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH W/WATER. SWEEP/SCOOP UP & REMOVE. PVNT
SPREAD/SPILL. CONFINE SPILL. STOP LEAK @ SOURCE IF THIS CAN BE DONE
SAFELY. BE SURE AREA IS WELL VENTILATED. TRANSFER MATL INTO DRUMS
FOR DISP. WASH AREA W /WATER. RESIDUAL AMTS SHOULD BE
FLUSHEDTO(SUPDAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT GET IN EYES, ON SKIN OR
CLOTHING.
Other Precautions:DO NOT BREATHE DUST, VAPOR, MIST, GAS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AVOID BRTHG VAP/MIST/DUST. USE NIOSH APPRVD FULL
FACE RESP WHEN AIRBORNE EXPOS IS LIKELY. IF USED, NIOSH APPRVD FULL
FACE PIECE REPLACES NEED FOR CHEM GOGGS & FACE SHIELD. IF EXPOS
CANNOT BE KEPT TO M IN W/ENGINEERING CTLS, USE NIOSH(SUPDAT)
Ventilation:LOC EXHAUST. ENGINEERING CTLS: INVESTIGATE ENGINEERING
TECHNIQUES TO REDUCE EXPOS BELOW AIRBORNE EXPOS LIMITS. (ING 8)
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER .
APRON.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
PH (5 % SOLN): >12. EFTS OF OVEREXP: SHOULD PAY SPEC ATTN TO REC EXPOS
LIMITS FOR HAZ INGREDS. FIRST AID PROC: FOR @ LST 15 MINS. HOLD
EYELIDS OPEN WHILE FLUSHING. INHAL: REMOVE TO FRESH AIR. IF NOT B
RTHG GIVE ARTF RESP. SPILL PROC: CHEM WASTE TREATMENT. RESP PROT:
APPRVD RESP EQUIP AS NOTED. OBSERVE RESP USE (ING 5)
================== Physical/Chemical Properties ==================
pH:SUPDAT
Evaporation Rate & Reference:NOT KNOWN
Solubility in Water:SOLUBLE
Appearance and Odor:WHITE, FREE FLOWING POWDER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, STRONG OXIDIZERS.
Stability Condition to Avoid:STRONG ACIDS, STRONG OXIDIZERS.
Hazardous Decomposition Products:THERMAL - OXIDES OF CARBON.
==================== Disposal Considerations ====================
Waste Disposal Methods:ABSORB WITH NON-COMBUSTIBLE MATL & PLACE IN DOT
APPRVD WASTE CONTAINERS. KEEP OUT OF SEWERS, STORM DRAINS & SURFACE
WATERS. CONSULT FEDERAL, STATE, OR LOCAL AUTHORITIES FOR PROPER
DISPOSAL PROCEDURES.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:M26305 N-METHYLACETAMIDE 99+%
CAGE:21076
CAGE:60928
CAGE:63181
CAGE:21076
============= Composition/Information on Ingredients =============
Ingred Name:N-METHYLACETAMIDE *98-1*
CAS:79-16-3
RTECS #:AC5960000
Fraction by Wt: >99%
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(RAT): 5 GM/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:HARMFUL IF SWALLOWED, INHALED/ABSORBED
THROUGH SKIN. VAPORS/MIST IS IRRITATING TO THE EYES, MUCOUS
MEMBRANES & UPPER RESPIRATORY TRACT. CAUSES SKIN IRRITATION. MAY
CAUSE CONGENITAL MALFORMATION IN THE FETUS. MAY AFFECT THE LIVER,
PANCREAS,SPLEEN & TESTES. TERATOGEN. MAY CAUSE HARM TO THE UNBORN
CHILD.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION
======================= First Aid Measures =======================
First Aid:EYES/SKIN: IMMEDIATELY FLUSH W/COPIOUS AMOUNTS OF WATER FOR
15 MINS. INHALATION: REMOVE TO FRESH AIR. GIVE CPR/OXYGEN IF
NECESSARY. INGESTION: WASH OUT MOUTH W/WATER IF CONSCIOUS. OBTAIN
MEDICAL ATTEN TION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:227F
Extinguishing Media:WATER SPRAY, CO2, DRY CHEMICAL POWDER, APPROPRIATE
FOAM
Fire Fighting Procedures:WEAR SELF CONTAINED BREATHING APPARATUS &
PROTECTIVE CLOTHING TO PREVENT CONTACT W/SKIN & EYES.
Unusual Fire/Explosion Hazard:EMITS TOXIC FUMES UNDER FIRE CONDITIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE AREA. WEAR SCBA, RUBBER BOOTS & HEAVY
CONTAINER & HOLD FOR WASTE DISPOSAL. VENTILATE AREA & WASH SITE
AFTER MATERIAL PICKUP IS COMPLETE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE. KEEP
TIGHTLY CLOSED. STORE UNDER NITROGEN. WEAR SUITABLE PROTECTIVE
Other Precautions:DON'T BREATHE VAPOR. DON'T GET IN EYES, ON SKIN/ON
CLOTHING. AVOID PROLONGED/REPEATED EXPOSURE. NO SMOKING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR APPROPRIATE NIOSH/MSHA-APPROVED RESPIRATOR.
Ventilation:USE ONLY IN A CHEMICAL FUME HOOD.
Other Protective Equipment:PROTECTIVE CLOTHING, SAFETY SHOWER, EYE BATH
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING & SHOES
BEFORE REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:399-402.8F
Melt/Freeze Pt:M.P/F.P Text:78.8-82.4F
Spec Gravity:0.957
Appearance and Odor:WHITE CRYSTALLINE SOLID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Hazardous Decomposition Products:CO, CO2, NITROGEN OXIDES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISSOLVE/MIX THE MATERIAL W/A COMBUSTIBLE
SOLVENT & BURN IN A CHEMICAL INCINERATOR EQUIPPED W/AN AFTERBURNER
& SCRUBBER. DISPOSE OF IAW/LOCAL, STATE & FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:GC-12 PROTECTIVE SHIELD CLEANER #1328
Preparer's Name:F.C.
CAGE:93607
CAGE:93607
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: PROPRIE
Other REC Limits:NONE RECOMMENDED
Ingred Name:ISOPROPYL ALCOHOL (SARA 313)
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: PROP
Other REC Limits:NONE RECOMMENDED
OSHA PEL:400 PPM
ACGIH TLV:400 PPM
Ingred Name:DIMETHYL SILOXANE
CAS:63148-62-9
RTECS #:JT6484500
Fraction by Wt: PROP
Other REC Limits:NONE RECOMMENDED
Ingred Name:2-BUTOXYETHANOL
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: PROP
Other REC Limits:NONE RECOMMENDED
OSHA PEL:25 PPM
ACGIH TLV:25 PPM
Ingred Name:2-AMINO ETHANOL
CAS:141-43-5
RTECS #:KJ5775000
Fraction by Wt: PROP
Other REC Limits:NONE RECOMMENDED
OSHA PEL:3 PPM
ACGIH TLV:3 PPM
===================== Hazards Identification =====================
LD50 LC50 Mixture:NOT EST.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE EYE IRRITATION. INGESTION:
MAY CAUSE GASTRIC DISTRESS & SYSTEMIC INTOXICATION.
Explanation of Carcinogenicity:NO
======================= First Aid Measures =======================
First Aid:EYE: FLUSH THOROUGHLY W/WATER UNTIL IRRITATION SUBSIDES. IF
IRRITAITON PERSISTS GET MEDICAL AID. INGESTION: DON'T INDUCE
VOMITING. GIVE WATER. CALL DR.
===================== Fire Fighting Measures =====================
Flash Point Method:TOC
Flash Point:NONE TO BOILING
Lower Limits:NOT EST.
Upper Limits:NOT EST.
Unusual Fire/Explosion Hazard:HEATED PRODUCTS MAY LIBERATE TOXIC FUMES.
WEAR SCBA.
================== Accidental Release Measures ==================
Spill Release Procedures:RECONTAINERIZE BY MOPPING, WET VACUUM OR
SUITABLE ABSORBENT. RINSE REMAINING MATERIAL TO DRAINS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE BETWEEN 40 & 120F.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. FOR SALE, USE, STORAGE
BY SERVICE PERSONNEL ONLY
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED
Ventilation:NONE
Other Protective Equipment:NONE
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:AS WATER
Vapor Density:AS WATER
Spec Gravity:0.990
pH:10.0
Evaporation Rate & Reference:AS WATER
Solubility in Water:DISPERSES
Appearance and Odor:OPAQUE, THIN, WHITE LIQUID, ALCOHOL ODOR.
Percent Volatiles by Volume:96.7
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:FOLLOW LOCAL, STATE, FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:26000 UNLEADED REGULAR GASOLINE, 00356
CAGE:2R503
CAGE:3R503
CAGE:2R503
============= Composition/Information on Ingredients =============
Ingred Name:GASOLINE % WT: 95.00-99.99
CAS:8006-61-9
RTECS #:LX3300000
Fraction by Wt: <99.99%
OSHA PEL:300 PPM
ACGIH TLV:300 PPM; 500 STEL
Ingred Name:ETHER, TERT-BUTYL METHYL; (METHYL-T-BUTYL ETHER) (SARA 313)
(CERCLA) % WT: 10.00-19.99
CAS:1634-04-4
RTECS #:KN5250000
Fraction by Wt: <19.99%
OSHA PEL:N/K
ACGIH TLV:N/K
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:ETHER, TERT-BUTYL ETHYL; (ETHYL-T-BUTYL ETHER) % WT:
10.00-19.99
CAS:637-92-3
RTECS #:KN4730200
Fraction by Wt: <19.99%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:TERT-AMYL METHYL ETHER % WT: 10.00-19.99
CAS:994-05-8
RTECS #:EK4421000
Fraction by Wt: <19.99%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ETHYL ALCOHOL
CAS:64-17-5
RTECS #:KQ6300000
Fraction by Wt: 3-9.99%
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM
Ingred Name:XYLENE (SARA 313) (CERCLA)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 3-9.99%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM; 150 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:TOLUENE (SARA 313) (CERCLA)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 3-9.99%
OSHA PEL:200 PPM
ACGIH TLV:50 PPM, S
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:BENZENE (SARA 313) (CERCLA)
CAS:71-43-2
RTECS #:CY1400000
Fraction by Wt: 1-2.99%
OSHA PEL:N/K
ACGIH TLV:10 PPM
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:BENZENE, 1,2,4-TRIMETHYL-; (1,2,4-TRIMETHYLBENZENE) (SARA
313)
CAS:95-63-6
RTECS #:DC3325000
Fraction by Wt: 1-2.99%
OSHA PEL:25 PPM
ACGIH TLV:25 PPM
Ingred Name:HEXANE; (N-HEXANE) (CERCLA)
CAS:110-54-3
RTECS #:MN9275000
Fraction by Wt: 1-2.99%
OSHA PEL:500 PPM
ACGIH TLV:50 PPM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:BENZENE, ETHYL-; (ETHYLBENZENE) (SARA 313)
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: 1-2.99%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM; 125 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:VOLATILE ORGANIC COMPOUND: NOT DETERMINED
RTECS #:9999999VO
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPDAT: OSHA REGULATED: 29 CFR 1910.1028.
RTECS #:9999999ZZ
Ingred Name:EFTS OF OVEREXP: SEVERAL MOUTHFULS SWALLOWED, ABDOM
DISCOMFORT, NAUS & DIARR MAY OCCUR. ASPIR MAY OCCUR DURING (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14: SWALLOW/VOMIT RSLTG IN LUNG DMG. CHRONIC:TOLUENE
APPEARS ON THE NAVY LIST OF OCCUP CHEM REPRO HAZS. (ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15: CONSULT APPROP HLTH PROFESSIONALS CONCERNING LATEST
HAZ LIST & SAFE HNDLG & EXPOS INFO . FOR MORE (ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16: INFO ON HEALTH HAZS, CONTACT NEHC .
RTECS #:9999999ZZ
Ingred Name:FIRST AID:ANYTHING BY MOUTH IF UNCON/CONVULSING.
INHAL:REMOVE TO FRESH AIR. IF NOT BRTHG/IN RESP DISTRESS, START(ING
19)
RTECS #:9999999ZZ
Ingred Name:ING 18: ARTF RESP. W/MD'S ADVICE GIVE OXYG. OTHER:ASPIR
DURING INDUCED EMESIS MAY RSLT IN SEV LUNG INJURY. IF (ING 20)
RTECS #:9999999ZZ
Ingred Name:ING 19: STOM EVACUATION IS NEC, USE METH LST LIKELY TO
CAUSE ASPIR SUCH AS GASTRIC LAVAGE AFTER ENDOTRACHEAL (ING 21)
RTECS #:9999999ZZ
Ingred Name:ING 20: INTUBATION. CNTCT POIS CTR FOR ADDNL TREATMENT
INFO. CNTCT NEHC FOR MORE SPECIFIC INFO .
RTECS #:9999999ZZ
Ingred Name:SPILL PROC: AIRBORNE CONC OF CONTAMINANT/OXYG UNKNOWN.
OTHERWISE, WEAR RESP PROT & PPE AS APPROP. CNTN SPILL. (ING 23)
RTECS #:9999999ZZ
Ingred Name:ING 22: REMOVE W/INERT ABSORB. PVNT ENTRY INTO SEWERS &
WATERWAYS. IF >714 LBS SPILLED, REPORT AS NECESSARY.
RTECS #:9999999ZZ
Ingred Name:HNDLG/STOR: CNTNR, TRANSFER LINE & RECEIVING CNTNR. KEEP
AWAY FROM HEAT, SPKS, FLAME & OTHER SOURCES OF IGNITION.
RTECS #:9999999ZZ
Ingred Name:VENT:MIXS & AVOID SIGNIFICANT OXYG DISPLACEMENT. OXYG
LEVELS SHOULD BE AT LST 19.5% IN CONFINED SPACES/OTHER WORK AREAS.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50: (ORAL, RAT) >5 G/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: EYE:IRRIT EXPERIENCED AS MILD
DISCOMFORT & SLIGHT EXCESS REDNESS. SKIN:BRIEF CNTCT MAY CAUSE
SLIGHT IRRIT. PRLNGD CNTCT AS W/CLTHG WETTED W/MATL, MAY CAUSE MORE
SEV IRRIT & DISCOMFORT SEEN AS L OC REDNESS & SWELL. PRLNGD,
WIDESPREAD OR RPTD CNTCT MAY RSLT IN ABSORPTION OF POTNTLY HARMFUL
AMTS OF (EFTS OF OVEREXP)
Explanation of Carcinogenicity:GASOLINE:IARC MONO, VOL 45, PG 159,
1989:GRP 2B. BENZENE:IARC MONO, SUPP, VOL 7, PG 120, 1987:GRP 1.
NTP 7TH (SUPDAT)
Effects of Overexposure:HLTH HAZ: MATL. INHAL: VAPS/MIST MAY CAUSE
SLIGHT NOSE & THROAT IRRIT. MAY CAUSE DIZZ, DROW, EUPHORIA, LOSS OF
COORD, DISORIENTATION, HDCH, NAUS & VOMIT. IN POORLY VENTD
AREA/CONFINED SPACE UNCON & AS PHY MAY RSLT. PRLNGD/RPTD OVEREXP
MAY RSLT IN ABSORPTION OF POTNTLY HARMFUL AMTS OF MATL. INGEST:IF
MORE THAN (ING 14)
Medical Cond Aggravated by Exposure:BECAUSE OF ITS IRRITATING
PROPERTIES, REPEATED SKIN CONTACT MAY AGGRAVATE AN EXISTING
DERMATITIS (SKIN CONDITION).
======================= First Aid Measures =======================
First Aid:EYES:IMMED FLUSH W/PLENTY OF WATER FOR AT LST 15 MIN. HOLD
LIDS APART. GET MED ATTN. SKIN:WASH W/PLENTY OF SOAP & WATER FOR
SEVERAL MIN. GET MED ATTN IF IRRIT DEVELOPS/PERSISTS. INGEST:IF
CONSCIOUS & CAN SWALLOW, GIVE 2 GLASSES OF WATER (16OZ) BUT DO NOT
INDUCE VOMIT. IF VOMIT OCCURS, GIVE FLUIDS AGAIN. HAVE MED PERS
DETERM IF EVACUATION OF STOM OR INDUCTION OF VOMIT IS NEC. DO NOT
GIVE (ING 18)
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:-40F,-40C
Lower Limits:1.4%
Upper Limits:7.6%
Extinguishing Media:USE WATER SPRAY, DRY CHEMICAL, ALCOHOL RESISTANT
FOAM OR CARBON DIOXIDE TO EXTINGUISH FIRE.
Fire Fighting Procedures:USE NIOSH APPRVD SCBA & FULL PROT EQUIP .
WATER MAY BE INEFTIVE ON FLAMES BUT SHOULD BE USED TO COOL
FIRE-EXPOS CNTNRS & PROVIDE PROT FOR PERS (SUPDAT)
Unusual Fire/Explosion Hazard:GASOLINE VAPS ARE HVR/AIR & MAY TRAVEL
CONSIDERABLE DIST TO IGNIT SOURCE & FLASH BACK. FLOWING GASOLINE
CAN GENERATE STATIC ELEC & CAUSE FIRE EXPLO IF (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:ELIM IGNIT SOURCES INCL INTERNAL COMBUST
ENGINES & POWER TOOLS. VENT AREA. BARRICADE HAZ AREA. STAY UPWIND &
WARN OF POSS DOWNWIND EXPLO HAZ. AVOID BRTHG VAP & CNTCT W/SKIN,
EYES/CLTHG. WEAR NIOSH APP RVD PRESS DEMAND AIR SUPPLIED RESPS WHEN
(ING 22)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE SPK-PROOF TOOLS. MATL MAY BE AT
ELEVATED TEMPS &/OR PRESS. EXERCISE CARE WHEN OPENING BLEEDERS &
SAMPLING PORTS. GROUND & BOND SHIPPING (ING 24)
Other Precautions:EMPTY CNTNRS CAN BE HAZ IF USED TO STORE TOXIC, FLAM
OR REACTIVE MATLS. CUTTING/WELDING EMTPY CNTNRS MAY CAUSE FIRE,
EXPLO OR TOXIC FUMES FROM RESIDUES. DO NOT PRESSURIZE OR EXPOSE TO
OPEN FLAME/HEAT. KEEP CNTNR CLSD & DRUM BUNGS IN PLACE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF OCCUP EXPOS LIM OF PROD/ANY COMPONENT
EXCEEDED USE APPROP NIOSH APPRVD AIR PURIFYING OR AIR SUPPLIED RESP
AFTER DETERM AIRBORNE CONC. WEAR NIOSH APPRVD AIR SUPPLIED RESPS
WHEN AIRBORNE CONC OF CONT AMINANT OR OXYG CONTENT UNKNOWN.
Ventilation:USE EXPLO-PROOF EQUIP TO MAINTAIN ADEQ VENT TO MEET OCCUP
EXPOS LIMS. IF APPLIC, PVNT ACCUM OF EXPLO AIR-GAS (ING 25)
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER. PROT
CLTHG SUCH AS COVERALLS/BOOTS. LAUNDER/DRY CLEAN SOILED CLOTHES.
Work Hygienic Practices:DRY CLEANING MAY BE MORE EFTIVE THAN NORM
LAUNDERING. INFORM CLEANER OF POTNTL HAZS ASSOC W/HNDLG CONTAM
CLTHG.
Supplemental Safety and Health
SPEC GRAV: 0.7-0.77 (H*2O=1). VP: 300-700 @ 100. FIRE FIGHT PROC:
ATTEMPTING TO STOP LEAK. EXPLO HAZ: SPK OCCURS IN FLAM VAP-AIR ATM.
WHEN HNDLG, USE NON-SPKG TOOLS, GROUND & BOND ALL CNTNRS. EXTREMEL
Y FLAM; CAN BE IGNITED BY HEAT, SPK OR FLAME. EXPLAN OF CARCIN:
ANNUAL RPT ON CARCINS, 1991:KNOWN TO BE CARCIN.(ING 13)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>90F,>32C
Vapor Pres:SUPDAT
Vapor Density:3-4
Spec Gravity:SUPDAT
Solubility in Water:0.1-1%
Appearance and Odor:LIGHT RED TO LIGHT STRAW LIQUID; PETROLEUM ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
REACTS VIOLENTLY WITH STRONG OXIDIZERS.
Stability Condition to Avoid:REACTS VIOLENTLY WITH HEAT.
Hazardous Decomposition Products:TOXIC LEVELS OF CARBON MONOXIDE,
CARBON DIOXIDE, IRRITATING ALDEHYDES AND KETONES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISP MUST BE I/A/W FED, STATE & LOCAL REGS .
PROD HAS RCRA CLASSIFICATION OF BENZENE TOX & IGNIT. IF DISCARDED
IN PRESENT FORM HAZ WASTE #S D018 & D001. DO NOT ALLOW TO ENTER
DRAINS/SEWERS. CANCAUSE EXPLO. CNTCT NEHC FOR MORE INFO .
| 1 | gloves_mandatory |
=======================================================
NIIN: 00-910-8154
Product ID: SO-SURE BLACK 37038 (0054-390)
Cage: 0FTT5
=======================================================
Preparer Co. when other than Responsible Party Co.
=======================================================
Cage: 0FTT5
=======================================================
Contractor Summary
=======================================================
Cage: 0FTT5
=======================================================
Item Description Information
=======================================================
Item Manager: GSA
Item Name: ENAMEL
Specification Number: TT-E-516A
Unit of Issue: PT
UI Container Qty: 0
=======================================================
Ingredients
=======================================================
Cas: 108-88-3
RTECS #: XS5250000
% Wt: 14.66
Other REC Limits: NONE RECOMMENDED
OSHA PEL: 200 PPM
ACGIH TLV: 100 PPM
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
------------------------------
Cas: 67-64-1
RTECS #: AL3150000
% Wt: 23.09
Other REC Limits: NONE RECOMMENDED
OSHA PEL: 1000 PPM
ACGIH TLV: 750 PPM
EPA Rpt Qty: 5000 LBS
DOT Rpt Qty: 5000 LBS
------------------------------
Cas: 1330-20-7
RTECS #: ZE2100000
% Wt: 3.78
Other REC Limits: NONE RECOMMENDED
OSHA PEL: 100 PPM
ACGIH TLV: 100 PPM
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
------------------------------
Cas: 100-41-4
RTECS #: DA0700000
% Wt: <1.89
Other REC Limits: NONE RECOMMENDED
OSHA PEL: 100 PPM
ACGIH TLV: 100 PPM
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
------------------------------
Cas: 74-98-6
RTECS #: TX2275000
% Wt: 14.90
Other REC Limits: NONE RECOMMENDED
OSHA PEL: 1000 PPM
ACGIH TLV: 1000 PPM
------------------------------
Cas: 75-28-5
RTECS #: TZ4300000
% Wt: 3.66
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: 800 PPM
------------------------------
Cas: 106-97-8
RTECS #: EJ4200000
% Wt: 5.86
Other REC Limits: NONE RECOMMENDED
OSHA PEL: 800 PPM
ACGIH TLV: 800 PPM
------------------------------
Cas: 108-65-6
RTECS #: AI8925000
% Wt: 1.89
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: NOT ESTABLISHED
------------------------------
Cas: 8032-32-4
RTECS #: OI6180000
% Wt: 11.35
Other REC Limits: NONE RECOMMENDED
OSHA PEL: 100 PPM
ACGIH TLV: 100 PPM
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: EYE: IRRIT. SKIN: IRRIT. INHAL: HARMFUL, FATAL, BRAIN/NS
DAMAGE, ANESTHETIC, RESPIRATORY TRACT IRRIT, LIGHT HEADEDNESS, STAGGERING
GAIT, GIDDY, NAUSEA, THROAT IRRIT, HEADACHE, VOMIT. INGEST: HARMFUL.
Medical Cond Aggravated By Exposure: RESPIRATORY AILMENTS
First Aid: EYE: FLUSH W/WATER FOR 15 MINUTES. SKIN: WASH W/SOAP & WATER.
WASH CLOTHES BEFORE REUSE. INHAL: REMOVE TO FRESH AIR. ARTIF RESP IF NEEDED.
INGEST: DONT INDUCE VOMIT. IN ALL CASES, GET MEDICAL ATTENTIO N.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: REMOVE ALL SOURCES OF IGNITION AND VENTILATE AREA.
MOP SPILLS WITH INERT ABSORBENT. AVOID BREATHING VAPORS.
Waste Disposal Methods: IN ACCORDANCE W/FEDERAL, STATE, LOCAL REGULATIONS. DONT
PUNCTURE, INCINERATE OR STORE >120F. EXPOSURE TO HEAT OR PROLONGED
EXPOSURE TO SUN MAY CAUSE CAN TO BURST. DISCARD EMPTY CAN IN TRASH PICK-UP. D
ONT PLACE IN HOME TRASH COMPACTOR.
Handling And Storage Precautions: KEEP OUT OF REACH OF CHILDREN. CONTENTS UNDER
PRESSURE. DONT STORE WHERE TEMPERATURE MAY EXCEED 120F.
Other Precautions: USE WITH GOOD VENTILATION. READ ENTIRE LABEL BEFORE USING.
FOLLOW ALL LABEL DIRECTIONS.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: -156F,-104C
Lower Limits: 1.8
Upper Limits: 9.5
Extinguishing Media: CARBON DIOXIDE, DRY CHEMICAL, FOAM, SAND, WATER SPRAY.
AVOID SPREADING ANY BURNING LIQUID WITH WATER SPRAY.
Fire Fighting Procedures: WATER MAY BE INEFFECTIVE. USE WATER TO COOL
CONTAINERS. USE SCBA. USE SHIELDING TO PROTECT PERSONNEL FROM BURSTING,
RUPTURING OR VENTING OF CONTAINERS.
Unusual Fire/Explosion Hazard: DONT SPRAY NEAR OPEN FLAME. AT ELEVATED
TEMPERATURE (>120F) CONTAINERS MAY VENT, RUPTURE OR BURST. AEROSOL
CONTAINER: DONT EXPOSE TO TEMPERATURE ABOVE 120F.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NONE BELOW TLV. USE NIOSH/MSHA APPROVED MASK ABOVE TLV.
Ventilation: LOCAL EXHAUST PREFERRED. MECHANICAL (GENERAL) ACCEPTABLE AT POINT
OF MIST OR SPRAY RELEASE.
Other Protective Equipment: IMPERVIOUS CLOTHES TO PROTECT SKIN. EYE WASH
STATION.
Work Hygienic Practices: USE GOOD PERSONAL HYGIENE. DONT EAT OR SMOKE WHILE
USING PRODUCT.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: NA
M.P/F.P Text: NA
Decomp Text: NA
Vapor Pres: 60 @ 68F
Vapor Density: >1.5 AIR=1
Spec Gravity: 0.798 AEROSOL
PH: NA
VOC Grams/Liter: 452
Solubility in Water: INSOLUBLE
Appearance and Odor: BLACK PAINT
Corrosion Rate: NA
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: EXTREME HEAT
Materials To Avoid: NA
Hazardous Decomposition Products: CARBON MONOXIDE AND POSSIBLE HYDROGEN
CHLORIDE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NA
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
Other Information: VOC = 452 G/L
=======================================================
Transportation Information
=======================================================
Trans ID NO: 91463
Product ID: SO-SURE BLACK 37038 (0054-390)
Review Date: 03/24/1998
Multiple KIT Number: 0
Review IND: Y
Unit Of Issue: PT
Container QTY: 0
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: DTJ
Symbols: D
DOT Proper Shipping Name: CONSUMER COMMODITY
Hazard Class: ORM-D
Label: NONE
Non Bulk Pack: 156,306
Bulk Pack: NONE
Max Qty Pass: 30KGGROSS
Max Qty Cargo: 30KGGROSS
Vessel Stow Req: A
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: AKH
IMO Proper Shipping Name: AEROSOLS/AEROSOL PRODUCT ?
IMDG Page Number: SEE 9022
UN Number: 1950
UN Hazard Class: 9?
IMO Packaging Group: -
Subsidiary Risk Label: -
EMS Number: 2-13
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: ALS
IATA UN ID Num: 1950
IATA Proper Shipping Name: AEROSOLS, FLAMMABLE
IATA PSN Modifier: (EACH NOT EXCEEDING 1 L CAPACITY)
IATA UN Class: 2.1
IATA Label: FLAMMABLE GAS
Packing Note Passenger: 203
Max Quant Pass: 75KG
Max Quant Cargo: 150KG
Packaging Note Cargo: 203
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: ALR
AFI Symbols: *
AFI Proper Shipping Name: AEROSOLS, FLAMMABLE, N.O.S.
AFI PSN Modifier: (EACH NOT EXCEEDING 1L CAPACITY)
AFI Hazard Class: 2.1
AFI UN ID NUM: UN1950
Special Provisions: P4
Back Pack Reference: A6.3
=======================================================
HAZCOM Label
=======================================================
Product ID: SO-SURE BLACK 37038 (0054-390)
Cage: 0FTT5
Company Name: LHB INDUSTRIES
Street: 8833 FLEISCHER PLACE
Zipcode: 63134
Label Required IND: Y
Date Of Label Review: 10/12/1999
Status Code: A
Origination Code: G
Hazard And Precautions: EYE: IRRIT. SKIN: IRRIT. INHAL: HARMFUL, FATAL,
BRAIN/NS DAMAGE, ANESTHETIC, RESPIRATORY TRACT IRRIT, LIGHT HEADEDNESS,
STAGGERING GAIT, GIDDY, NAUSEA, THROAT IRRIT, HEADACHE, VOMIT. INGEST:
HARMFUL.
=======================================================
| 1 | gloves_mandatory |
=======================================================
Product ID: ALEX PLUS-ALL COLORS, 18135
Cage: 90300
Box: 277
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 90300
Box: 277
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: NO
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: EYE CONTACT: MAY CAUSE EYE IRRITATION. SKIN CONTACT:
PROLONGED OR REPEATED CONTACT WITH SKIN MAY CAUSE IRRITATION. INHALATION:
VAPOR MAY CAUSE NOSE AND THROAT IRRITATION. INGESTION: NONE KNOWN. CHRONI C:
PROLONGED OR REPEATED CONTACT WITH SKIN MAY CAUSE IRRITATION.
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: NONE KNOWN.
First Aid: EYES: FLUSH WITH LARGE QUANTITIES OF WATER FOR AT LEAST 15 MINUTES
AND UNTIL IRRITATION SUBSIDES. SKIN: WASH WITH SOAP AND WATER. INHALATION:
REMOVE TO FRESH AIR. INGESTION: DO NOT INDUCE VOMITING. CO MMENTS: CALL
MEDICAL (1-800-327-3874) IF ANY IRRITATION OR COMPLICATIONS ARISE FROM ANY
ROUTE OF ENTRY.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: USE ABSORBENT MATERIAL OR SCRAPE UP DRIED MATERIAL
AND PLACE INTO CONTAINERS.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE OF ACCORDING TO FED, STATE & LOCAL
STANDARDS. THIS PROD DOES NOT MEET THE DEFINITION OF HAZ WASTE ACCORDING TO
U.S. EPA HAZ WASTE MANAGEMENT REGS, 40 CFR 261. STATE & LOCAL
REGS/RESTRICTIONS A RE COMPLEX & MAY DIFFER FROM FED REGS. (SUPDAT)
Handling And Storage Precautions: STORE AWAY FROM CAUSTICS & OXIDIZERS.
KEEP CNTNRS TIGHTLY CLOSED WHEN NOT IN USE. KEEP CNTNRS FROM EXCESSIVE HEAT
& FREEZING. DO NOT STORE (SUPDAT)
Other Precautions: KEEP OUT OF REACH OF CHILDREN. AVOID PROLONGED OR REPEATED
CONTACT WITH SKIN. AVOID CONTACT WITH EYES.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: SCC
Flash Point Text: >200F,>93C
Extinguishing Media: CARBON DIOXIDE, DRY CHEMICAL, FOAM, WATER FOG.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA AND FULL PROTECTIVE EQUIPMENT
(FP N).
Unusual Fire/Explosion Hazard: NONE KNOWN.
=======================================================
Control Measures
=======================================================
Respiratory Protection: A RESP PROT PROGRAM THAT MEETS OSHA 1910.134 & ANSI
Z88.2 REQS MUST BE FOLLOWED WHENEVER WORKPLACE CONDITIONS WARRANT A RESP'S
USE. NOT REQD UNDER NORMAL USAGE & ADEQ VENT. USE NIOSH APPRVD RESP APPRO
PRIATE FOR EXPOSURE OF CONCERN (FP N).
Ventilation: NORMAL ROOM VENTILATION.
Other Protective Equipment: ANSI APPROVED EYE WASH & DELUGE SHOWER (FP N).
Work Hygienic Practices: ALTHOUGH THIS PROD IS NOT CONSIDERED EYE IRRITANT,
INHAL HAZ OR SKIN CNTCT HAZ UNDER NORMAL CNDTNS, IT IS (SUPDAT)
Supplemental Safety and Health: WASTE DISP METH: RESPONSIBILITY FOR PROPER
WASTE DISPOSAL IS W/THE OWNER OF THE WASTE. EPA WASTE CODE - IF DISCARDED (40
CFR 261): NONE. HNDLG/STOR PRECS: AT TEMPS ABOVE 120F. HYGIENE PRACT:
ADVISABLE THAT PERS MINIMIZE SKIN CNTCT, INHAL OF VAPS & EYE CONTACT.
WASH CONTAM CLTHG BEFORE REUSE.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: >210F,>99C
Vapor Pres: 17 @ 68F
Vapor Density: HVR/AIR
Spec Gravity: 1.65-1.70
Evaporation Rate & Reference: SLOWER THAN BUTYL ACETATE
Solubility in Water: NEGLIGIBLE
Appearance and Odor: COLORED PASTE; SLIGHT AMMONIA ODOR.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: EXCESSIVE HEAT AND FREEZING.
Materials To Avoid: STRONG OXIDIZERS AND CAUSTICS.
Hazardous Decomposition Products: NORMAL DECOMPOSITION PRODUCTS, IE CO*X, NO*X.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: ALEX PLUS-ALL COLORS, 18135
Cage: 90300
Company Name: DAP INC.
PO Box: 277
Zipcode: 45401-0277
Label Required IND: Y
Date Of Label Review: 08/06/1998
Status Code: C
Label Date: 08/06/1998
Origination
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: COMBUSTIBLE. ACUTE: EYE CONTACT: MAY CAUSE EYE
IRRITATION. SKIN CONTACT: PROLONGED OR REPEATED CONTACT WITH SKIN MAY CAUSE
IRRITATION. INHALATION: VAPOR MAY CAUSE NOSE AND THROAT IRRITATION. CHRONIC:
PROLONGED OR REPEATED CONTACT WITH SKINMAY CAUSE IRRITATION.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SILICA GEL
CAGE:1BX64
CAGE:1BX64
CAGE:16210
============= Composition/Information on Ingredients =============
Ingred Name:SILICA GEL
CAS:63231-67-4
RTECS #:VV7322000
OSHA PEL:6 MG/M3
ACGIH TLV:10 MG/M3
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(ORAL,RAT) >31,600 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EPIDEMIOLOGICAL STUDIES INDICATE LOW
POTENTIAL FOR ADVERSE HLTH EFTS. SILICA GEL IS CONSIDERED BY
DAVISON TO BE A NUISANCE DUST. IN ACTIVATED FORM, SILICA GEL ACTS
AS A DESICCANT & CAN CAUSE DRYING IR RIT OF MUC MEMB & SKIN IN
CASES OF SEVERE EXPOS.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:DAVISON KNOWS OF NO MEDICAL
CONDITIONS ABNORMALLY AGGRAVATED BY EXPOSURE TO SILICA GEL.
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY WASH FROM EYES WITH LARGE AMOUNTS OF WATER
FOR AT LEAST 15 MINUTES, OCCASIONALLY LIFTING UPPER & LOWER LIDS.
IF IRRITATION OCCURS AND PERSISTS, SEEK MD. SKIN: WASH WITH SOAP
AND WATE R. INGEST: MATERIAL WILL PASS THROUGH BODY NORMALLY. CALL
MD IMMEDIATELY . INHAL: REMOVE TO FRESH AIR.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Extinguishing Media:USE MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:NONE SPECIFIED BY MANUFACTURER.
Unusual Fire/Explosion Hazard:NON-FLAMMABLE.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP OR VACUUM UP OR FLUSH TO SEWER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP TIGHTLY SEALED TO PROTECT
QUALITY. WHEN POURING IN A CNTNR OF FLAM LIQ, GROUND BOTH CNTNRS
ELEC TO PVNT STATIC ELEC SPARK.
Other Precautions:AVOID PROLONGED BREATHING OF DUST OR CONTACT WITH
DUST WITH THE SKIN. NOT KNOWN TO HAVE ANY ADVERSE EFFECT ON THE
AQUATIV ENVIRONMENT. IT IS INSOLUBLE AND NON-TOXIC.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF DUSTY CONDITIONS PREVAIL, USE OF AN
NIOSH/MSHA APPROVED DUST MASK IS RECOMMENDED.
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:WEAR LONG SLEEVES.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:2.1
pH:SUPDAT
Solubility in Water:INSOLUBLE
Appearance and Odor:DRY WHITE GRANULES, BEADS OR POWDER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
REACTS WITH HF.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN AN APPROVED LANDFILL ACCORDING TO
FEDERAL, STATE AND LOCAL REGULATIONS. COVER PROMPTLY TO AVOID
BLOWING OF DUST.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:8R3824 BINDER TAPE
CAGE:26921
CAGE:26921
============= Composition/Information on Ingredients =============
Ingred Name:DIMER FATTY ACID, ETHYLENEDIAMINE, PIPERAZINE AZELAIC ACID
POLYMER
CAS:68139-70-8
Ingred Name:C36 FATTY ACID DIMER, AZELAIC ACID, ETHYLENEDIAMINE, C36
DIMER DIAMINE POLYMER
CAS:69012-93-7
Ingred Name:ETHYLENE-VINYL ACETATE COPOLYMER
(ACETIC ACID ETHENYL ESTER, POLYMER W/ETHENE) *95-1*
CAS:24937-78-8
Ingred Name:ROSIN ACID *95-1*
CAS:8050-09-7
Ingred Name:PARAFFIN WAX FUME, PARAFFIN
CAS:8002-74-2
RTECS #:RV0350000
ACGIH TLV:2 MG/CUM
Ingred Name:ACRYLONITRILE (SUSPECTED HUMAN CARCINOGEN BY ACGIH & IARC,
CONFIRMED ANIMAL CARCINOGEN BY IARC GROUP 2A) *95-1*
CAS:107-13-1
RTECS #:AT5250000
OSHA PEL:2 PPM
ACGIH TLV:4.3 MG/CUM (A2)
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:CELLULOSE
CAS:9004-34-6
RTECS #:FJ5691460
OSHA PEL:5 MG/CUM
ACGIH TLV:10 MG/CUM (DUST)
Ingred Name:ALUMINUM (POWDER) *95-1*
CAS:7429-90-5
RTECS #:BD0330000
Fraction by Wt: 5-10%
OSHA PEL:15 MG/CUM
ACGIH TLV:10 MG/CUM (DUST)
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EYES: MILD IRRITATION. SKIN: MILD
IRRITATION. MOLTEN ADHESIVE MAY CAUSE SEVERE BURNS.
Explanation of Carcinogenicity:SEE INGREDIENTS
Effects of Overexposure:IRRITATION & BURNS.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER. SKIN: WASH W/SOAP & WATER. IMMEDIATELY
COOL W/COLD WATER IF CONTACT W/MOLTEN ADHESIVE. INHALATION: REMOVE
TO FRESH AIR. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER, FOAM, CO2, DRY CHEMICAL.
Fire Fighting Procedures:FOR LARGE QUANTITIES INVOLVED IN A FIRE, USE
SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:CONSTITUENTS OF THIS MATERIAL ARE
COMBUSTIBLE.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED WHEN USED AS INTENDED.
Other Protective Equipment:NONE REQUIRED WHEN USED AS INTENDED
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Solubility in Water:NEGLIGIBLE
Appearance and Odor:ADHESIVE BINDER W/MINIMAL ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:OPEN FLAME & HIGH ELECTRIC ARC.
Hazardous Decomposition Products:CO, CO2 & OTHER TOXIC PRODUCTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:DESICCITE 25
CAGE:0FDV7
CAGE:0FDV7
============= Composition/Information on Ingredients =============
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 1-3%
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
Ingred Name:BENTONITE(INORGANIC CLAY)
CAS:1302-78-9
RTECS #:CT9450000
OSHA PEL:5 MG/M3 (DUST)
ACGIH TLV:5 MG/M3 (DUST)
===================== Hazards Identification =====================
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:IRRITATION TO EYES,SKIN AND
RESPIRATORY TRACT. CHRONIC:LUNGS DAMAGE.
Explanation of Carcinogenicity:LISTED AS A 2A BY IARC
Effects of Overexposure:MECHANICAL IRRITATION OF EYES AND SKIN.NO
ADVERSE EFFECTS ARE EXPECTED.INHALATION MAY CAUSE RESPIRATORY
IRRITATION AND MAY CAUSE LUNG DAMAGE IF EXPOSURE IS REPEATED OR
PROLONGED.
Medical Cond Aggravated by Exposure:MAY AGGRAVATE SKIN OR RESPIRATORY
PROBLEM.
======================= First Aid Measures =======================
First Aid:EYES AND SKIN:FLUSH WITH LARGE AMOUNT OF WATER FOR ABOUT
15-20 MINUTES;SEEK MEDICAL ATTENTION IMMEDIATELY.INHALATION:REMOVE
TO FRESH AIR;CALL A PHYSICIAN.INGESTION:SEEK MEDICAL ATTENTION
IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:USE CARBON DIOXIDE, FOAM, DRY CHEMICAL, OR WATER
FOG.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:NOT A FIRE OR EXPLOSION HAZARD.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL SPILL: WIPE UP, CONTAIN SPILLAGE AND
SCOOP UP OR VACUUM. AVOID DUSTING.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY AREA. KEEP
CONTAINERS TIGHTLY CLOSED WHEN NOT IN USE. PROTECT CONTAINERS FROM
PHYSICAL DAMAGE.
Other Precautions:PRODUCT BECOMES SLIPPERY WHEN WET.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR FOR DUST/MIST
IF ABOVE PEL/TLV.
Ventilation:LOCAL/GENERAL TO MAINTAIN PEL/TLV.
Other Protective Equipment:PROTECTIVE CLOTHINGS.EYE-WASH
FACILITIES,SAFETY SHOWER.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
DO NOT GET ON SKIN, IN EYES OR ON CLOTHING. DO NOT BREATHE DUST.
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:2.0
Solubility in Water:NEGLIGIBLE
Appearance and Odor:10 - 30 MESH GRANULES, GREYISH TO OFF-WHITE;
ORDERLESS.
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE EXPECTED.
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:NONE EXPECTED
==================== Disposal Considerations ====================
Waste Disposal Methods:CONSULT LOCAL AUTHORITIES;DISPOSAL MUST BE IN
ACCORDANCE WITH LOCAL,STATE AND FEDERAL REGULATIONS
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:3258 RED OXIDE INSTANT LACQUER PRIMER/SURFACER (IMPROVED)
CAGE:MART2
CAGE:MART2
============= Composition/Information on Ingredients =============
Ingred Name:TOLUENE
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 32%
Other REC Limits:375 MG/CUM
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ISOPROPANOL (ISOPROPYL ALCOHOL), 2-PROPANOL, DIMETHYL
CARBINOL
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 4%
Other REC Limits:400 PPM
OSHA PEL:400 PPM
ACGIH TLV:400 PPM
Ingred Name:HEXONE, METHYL ISOBUTYL KETONE (MIBK), 4-METHYL-2-PENTANONE
CAS:108-10-1
RTECS #:SA9275000
Fraction by Wt: 10%
Other REC Limits:50 PPM
OSHA PEL:100 PPM/75 STEL
ACGIH TLV:50 PPM/75 STEL; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:BUTYL ACETATE (N-BUTYL ACETATE)
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: 3%
Other REC Limits:150 PPM
OSHA PEL:700 MG/CUM
ACGIH TLV:713 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:DIBUTYL PHTHALATE, DI-N-BUTYL PHTHALATE
CAS:84-74-2
RTECS #:TI0875000
Fraction by Wt: 1%
Other REC Limits:5 MG/CUM
OSHA PEL:5 MG/CUM
ACGIH TLV:5 MG/CUM
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:TALC (POWDER), (ASBESTOS FREE), TALCUM; HYDROUS MAGNESIUM
SILICATE
CAS:14807-96-6
RTECS #:WW2710000
Fraction by Wt: 23%
OSHA PEL:20 MPPCF
ACGIH TLV:2 MG/CUM (RESP DUST)
Ingred Name:WEIGHT PER GALLON IN POUNDS: 9.55
RTECS #:9999999WG
Ingred Name:VOL ORGANIC CMPD: TOTAL VOLATILE ORGANIC COMPOUNDS & LESS
WATER & EXEMPT SOLVENTS 4.72
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: IRRITATION/ALLERGIC REACTION.
INHALATION: IRRITATION/ALLERGIC REACTION TO RESPIRATORY
SYSTEM/FATAL. PROLONGED OVEREXPOSURE TO SOLVENTS CAUSES ADVERSE
EFFECTS TO LIVER/URINARY/BLOOD FORMING/REPRO DUCTIVE/CARDIOVASCULAR
SYSTEMS/PERMANENT BRAIN/NERVOUS SYSTEM DAMAGE. ALCOHOL & ACETATE
ABSORPTION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: HEADACHE/DIZZINESS/NAUSEA/LOSS OF
COORDINATION/IRRITATION OF RESPIRATORY SYSTEM, UNCONSCIOUSNESS,
DEATH. SKIN/EYES: REDNESS/ITCHING/BURNING SENSATION/IRRITATION.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. SKIN: WASH AFFECTED AREA
THOROUGHLY W/SOAP & WATER. EYES: FLUSH W/LARGE AMOUNTS OF WATER FOR
15 MINS. INGESTION: OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:22F
Lower Limits:0.7%
Upper Limits:12.7%
Extinguishing Media:CO2, DRY CHEMICAL, FOAM
Fire Fighting Procedures:FULL PROTECTIVE EQUIPMENT INCLUDING SCBA.
WATER SPRAY MAY BE INEFFECTIVE. IF WATER IS USED, FOG NOZZLES ARE
PREFERRABLE.
Unusual Fire/Explosion Hazard:WATER MAY BE USED TO COOL CLOSED
CONTAINERS TO PREVENT PRESSURE BUILD-UP, POSSIBLE AUTOIGNITION, OR
EXPLOSION WHEN EXPOSED TO EXTREME HEAT. FLAMMABLE.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE IGNITION SOURCES. VENTILATE AREA/REMOVE
W/INERT ABSORBENT.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T SMOKE IN AREA. AVOID CONTACT
W/SKIN/EYES. USE APPROVED BONDING/GROUNDING PROCEDURE. KEEP FROM
CHILDREN. FLAMMABLE.
Other Precautions:KEEP CONTAINER TIGHTLY CLOSED WHEN NOT IN USE.
TRANSFER ONLY TO APPROVED CONTAINERS W/COMPLETE/APPROPRIATE
LABELING. INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING/INHALING
CONTENTS CAN BE HARMFUL/F ATAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR PROPERLY FITTED ORGANIC VAPOR/PARTICULATE
RESPIRATOR APPROVED BY NIOSH/MSHA FOR PROTECTION AGAINST MATERIALS.
WHEN SANDING/WIREBRUSHING/ABRADING/BURNING/WELDING DRIED FILM, WEAR
PARTICULATE RESPI RATOR APPROVED BY NIOSH/MSHA.
Ventilation:LOCAL EXHAUST: PREFERABLE. GENERAL EXHAUST ACCEPTABLE IF
EXPOSURE TO MATERIALS IS MAINTAINED BELOW APPLICABLE LIMITS.
Work Hygienic Practices:WASH HANDS AFTER USING. REMOVE/LAUNDER
CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
THIS COATING MAY CONTAIN MATERIALS CLASSIFIED AS NUISANCE PARTICULATES
WHICH MAY BE PRESENT AT HAZARDOUS LEVELS ONLY DURING
SANDING/ABRADING OF THE DRIED FILM. THIS MATERIAL IS
PHOTOCHEMICALLY REACTIV E. APPLICATIONS TO HOT SURFACES REQUIRES
SPECIAL PRECAUTIONS. AVOID BREATHING VAPORS/MIST. AVOID HEAT
SOURCES.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:132-302F
Vapor Density:>1
Spec Gravity:0.82-1.2
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:63-100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HEAT/ELECTRICAL EQUIPMENT/SPARKS/OPEN
FLAMES/HOT SURFACES/PILOT LIGHTS/HEATERS/STOVES/OTHER SOURCES OF
IGNITION
Hazardous Decomposition Products:CO2, CO
==================== Disposal Considerations ====================
Waste Disposal Methods:PRODUCT WASTE IS RCRA HAZARD. TEST FOR
IGNITABILITY TO DETERMINE APPLICABLE EPA HAZARDOUS WASTE NUMBER.
INCINERATE IN APPROVED FACILITY ACCORDING TO REGULATIONS. DON'T
INCINERATE CLOSED CONTAINERS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ISE CONDITIONING SOLUTION, (GLSAR378)
Preparer's Name:SHEILA ROMINE
CAGE:0ERJ7
CAGE:DUP0N
CAGE:0ERJ7
============= Composition/Information on Ingredients =============
Ingred Name:ISE CONDITIONING SOLN ACA5
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL:NO ADVERSE EFFECTS EXPECTED.
SKIN:NO ADVERSE EFFECTS EXPECTED. EYE:NO ADVERSE EFFECTS EXPECTED.
INGEST:NO ADVERSE EFFECTS EXPECTED.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:NO INFORMATION FOUND.
Medical Cond Aggravated by Exposure:NO INFORMATION FOUND.
======================= First Aid Measures =======================
First Aid:INHAL:NO SPECIFIC INTERVENTION IS INDICATED AS THE COMPOUND
IS NOT LIKELY TO BE HAZ BY INHAL.HOWEVER,CONSULT MD IF
NEC.SKIN:COMPOUND IS NOT LIKELY TO BE HAZ BY SKIN CONTACT,BUT
CLEANSING THE SKIN AFTE R USE IS ADVISABLE.EYE:NOT CONSIDERED
AHAZ.FLUSH EYE WITH WATER AS A PRECAUTION.INGEST:NO SPECIFIC
INTERVENTION IS INDICATED AS COMPOUND IS NOT LIKELY TO BE
HAZ.HOWEVER,CONSULT MD IF NEC.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER, WATER SPRAY, WATER FOG, CHEMICAL FOAM,
"ALCOHOL" FOAM, DRY POWDER (SAND OR MET-L-X), DRY CHEMICAL, CO*2.
Fire Fighting Procedures:EVACUATE PERSONNEL TO A SAFE AREA. KEEP
PERSONNEL REMOVED & UPWIND OF FIRE. WEAR NIOSH/MSHA APPROVED SCBA
AND FULL PROTECTIVE EQUIPMENT.
Unusual Fire/Explosion Hazard:HAZARDOUS GASES PRODUCED IN FIRE ARE
HYDROGEN FLUORIDE, AMMONIA, AND NITROGEN OXIDES.
================== Accidental Release Measures ==================
Spill Release Procedures:REVIEW FIRE&EXPLOSION HAZARDS&SAFETY
PRECAUTIONS BEFORE PROCEEDING WITH CLEAN UP.USE APPROPRIATE
PERSONAL PROTECTIVE EQUIPMENT DURING CLEAN UP.ABSORB ONTO
HAZORB(R)PILLOWS OR OTHER ABSORBENT.PLACE IN SUITABLE
CONTAINER.SEND TO DUMPSTER FORDISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NO RESTRICTIONS.
Other Precautions:AQUATIC TOXICITY: NO INFORMATION FOUND.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SPECIFIED BY MANUFACTURER.
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Melt/Freeze Pt:M.P/F.P Text:32.0F,0.0C
Vapor Pres:18 MMHG
Vapor Density:1.0
Spec Gravity:1.0 @ 20C
pH: 7
Evaporation Rate & Reference:1.0
Solubility in Water:100WT% @ 20C AQUEOUS
Appearance and Odor:COLORLESS AQUEOUS SOLUTION
Percent Volatiles by Volume:>99
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE REASONABLY FORESEEABLE.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:FLUSH TO SEWER FOLLOWING PROCEDURES OUTLINED IN
SP-9 OF THE GLASGOW SAFETY MANUAL.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:105, BUFFER SOLUTION 7.00 PH
CAGE:IO461
CAGE:IO461
CAGE:05668
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM MONOHYDROGEN PHOSPHATE (2:1:1); (DIBASIC SODIUM
PHOSPHATE) (CERCLA)
CAS:7558-79-4
RTECS #:WC4500000
Fraction by Wt: <3%
OSHA PEL:N/K
ACGIH TLV:N/K
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:METHANOL (SARA 313) (CERCLA)
CAS:67-56-1
RTECS #:PC1400000
Fraction by Wt: <4%
OSHA PEL:200 PPM, S
ACGIH TLV:200 PPM; 250 STEL, S
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:NON-HAZARDOUS INGREDIENTS
Fraction by Wt: >93%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: POSSIBLE IRRITATION TO EYES AND
SKIN.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:SEEK MEDICAL ASSISTANCE FOR FURTHER TREATMENT, OBSERVATION
AND SUPPORT IF NECESSARY. EYES: FLUSH WITH WATER FOR AT LEAST 15
MINUTES. SEEK MEDICAL ATTENTION IMMEDIATELY. SKIN: FLUSH WITH WATER
FOR 15 M INUTES. SEEK MEDICAL ATTENTION IF IRRITATION PERSISTS.
INHALATION: REMOVE TO FRESH AIR. INGESTION: INDUCE VOMITING. DILUTE
BY GIVING LARGE AMOUNTS OF WATER. SEEK MEDICAL ATTENTION
IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Extinguishing Media:WATER, ALCOHOL FOAM, CARBON DIOXIDE.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB SPILL WITH VERMICULITE OR SIMILAR
ABSORBENT. SWEEP UP AND PLACE IN DRY GARBAGE OR FLUSH SPILL TO
SEWER OR GROUND WITH LARGE AMOUNTS OF WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY AREA AWAY FROM ANY
REACTIVE MATERIALS OR CHEMICALS.
Other Precautions:NONE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
RUBBER APRON.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Spec Gravity:1.00 (H*2O=1)
Evaporation Rate & Reference:1.00 (H*2O=1)
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR OR GREEN COLORED LIQUID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ANY TYPE OF REACTIVE MATERIALS OR CHEMICALS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:AS PER LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:A286 INCO ALLOYS
CAGE:28553
CAGE:NO777
CAGE:28553
============= Composition/Information on Ingredients =============
Ingred Name:CHROMIUM (SARA 313) (CERCLA)
CAS:7440-47-3
RTECS #:GB4200000
Fraction by Wt: 15%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3; 9596
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:IRON
Fraction by Wt: 57%
Other REC Limits:NONE RECOMMENDED
Ingred Name:MOLYBDENUM
CAS:7439-98-7
RTECS #:QA4680000
Fraction by Wt: 1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:NICKEL (SARA 313) (CERCLA)
CAS:7440-02-0
RTECS #:QR5950000
Fraction by Wt: 26%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3; 9596
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION OF WELDING FUMES MAY
CAUSE NERVOUS SYSTEM AND MUSCLE IRREGULARITIES, IRRITATION OF EYES,
NOSE, THROAT, AND RESPIRATORY SYSTEM, METAL FUME FEVER. CHRONIC:
INHALATION OF FUMES MAY CAUS E CANCER, SIDEROSIS, FLUOROSIS AND
AFFECT LUNG FUNCTION.
Explanation of Carcinogenicity:CONTAINS NICKEL WHICH IS LISTED BY BOTH
IARC AND NTP.
Effects of Overexposure:INHALATION: NAUSEA, DIZZINESS,DRYNESS OF NOSE
AND THROAT, COUGHING, WHEEZING AND SHORTNESS OF BREATH. EYES:
REDNESS, TEARING, BLURRED VISION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. RESUSCITATE IF NEEDED. EYES:
FLUSH WITH PLENTY OF WATER FOR 15 MINUTES. SEE DOCTOR. SKIN: WASH
WITH SOAP AND WATER. INGESTION: DO NOT INDUCE VOMITING. SEE DOCTOR.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Extinguishing Media:NONE SPECIFIED BY MANUFACTURER. DLA-HMIS: USE MEDIA
APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures:NONE SPECIFIED BY MANUFACTURER.
Unusual Fire/Explosion Hazard:NON-FLAMMABLE; BUT SPARKS FROM WELDING OR
GRINDING MAY IGNITE COMBUSTIBLES DURING USE.
================== Accidental Release Measures ==================
Spill Release Procedures:PICK UP RODS. SWEEP UP OR MOP. PLACE RESIDUE
IN A CONTAINER FOR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:REMOVE ANY COMBUSTIBLES FROM WORK
AREA: SPARKS OR WELDING ARC COULD IGNITE NEARBY COMBUSTIBLES.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR FOR WELDING
FUMES OR SUPPLIED AIR RESPIRATOR IN CONFINED SPACES OR WHERE FUME
CONCENTRATION EXCEEDS REGULATORY LIMITS. USE IAW 29 CFR 1910.134.
Ventilation:USE MECHANICAL OR LOCAL EXHAUST OR BOTH TO MAINTAIN LEVELS
OF FUMES BELOW REGULATORY LIMITS.
Other Protective Equipment:CLOTHING TO PROTECT ENTIRE BODY FROM SPARKS.
Work Hygienic Practices:WASH HANDS AFTER USE AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:>2552F,>140
Spec Gravity:8-9
Appearance and Odor:SILVER COLORED METAL SHAPED AS PLATE, BAR, WIRE,
TUBE, ROD, STRIP, SHEET, ETC..
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:METAL FUMES, FLUORIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:06365 DEXTROSE ANHYDROUS BP350-1
CAGE:1B464
CAGE:1B464
============= Composition/Information on Ingredients =============
Ingred Name:D-GLUCOSE, DEXTROSE ANHYDROUS *97-4*
CAS:50-99-7
RTECS #:LZ6600000
Fraction by Wt: >99%
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(RAT): 25800 MG/KG GLUCOSE
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN: DUST MAY CAUSE MECHANICAL
IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/PLENTY OF WATER FOR 15 MINS. SKIN: FLUSH
W/PLENTY OF SOAP & WATER. INGESTION: IF CONSCIOUS & ALERT, GIVE 2-4
CUPFULS OF MILK/WATER. INHALATION: REMOVE TO FRESH AIR IMMEDIATELY.
OBTAIN ME DICAL ATTENTION IN ALL CASES. TREAT SYMPTOMATICALLY &
SUPPORTIVELY.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER SPRAY, DRY CHEMICAL/CO2
Fire Fighting Procedures:WEAR A SELF CONTAINED BREATHING APPARATUS IN
PRESSURE-DEMAND, MSHA/NIOSH APPROVED & FULL PROTECTIVE GEAR.
Unusual Fire/Explosion Hazard:DUSTS AT SUFFICIENT CONCENTRATIONS CAN
FORM EXPLOSIVE MIXTURES W/AIR.
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTIVE EQUIPMENT.
VACUUM/SWEEP UP MATERIAL & PLACE INTO A SUITABLE DISPOSAL
CONTAINER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE W/ADEQUATE VENTILATION. STORE IN A
COOL, DRY VENTILATED AREA AWAY FROM INCOMPATIBLE SUBSTANCES.
Other Precautions:MINIMIZE DUST GENERATION & ACCUMULATION. AVOID
CONTACT W/SKIN & EYES. AVOID INGESTION & INHALATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:ALWAYS USE A NIOSH-APPROVED RESPIRATOR WHEN
NECESSARY.
Ventilation:GOOD GENERAL VENTILATION SHOULD BE SUFFICIENT TO CONTROL
AIRBORNE LEVELS.
Other Protective Equipment:PROTECTIVE CLOTHING.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:295F
Vapor Pres:<0.1
Spec Gravity:1.54
pH:5.9
Solubility in Water:COMPLETE
Appearance and Odor:SOLID WHITE POWDER W/NO ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
SODIUM PEROXIDE & POTASSIUM NITRATE, STRONG OXIDIZERS
Hazardous Decomposition Products:CO, CO2
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:100 ROOF FOUNDATION COATING
CAGE:CENTU
CAGE:CENTU
============= Composition/Information on Ingredients =============
Ingred Name:ASPHALT FUMES, ASPHALT, CUTBACK ASPHALT
CAS:8052-42-4
RTECS #:CI9900000
Fraction by Wt: 70-95%
Other REC Limits:5 MG/CUM
ACGIH TLV:5 MG/CUM
Ingred Name:BENZIN, NAPHTHA, MINERAL SPIRITS, PETROLEUM NAPHTHA
CAS:8030-30-6
RTECS #:DE3030000
Fraction by Wt: 4-15%
Other REC Limits:STEL 400 PPM
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
Ingred Name:FIBERS, NATURAL (NON-ASBESTOS)
Fraction by Wt: 1-15%
ACGIH TLV:10 MG/CUM
Ingred Name:FIBERS, SYNTHETIC
Fraction by Wt: 1-15%
ACGIH TLV:10 MG/CUM
Ingred Name:CLAY (KAOLIN)
CAS:1332-58-7
RTECS #:GF1670500
Fraction by Wt: 1-15%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:2 MG/M3 TDUST; 9293
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: PROLONGED OR REPEATED CONTACT
MAY CAUSE MILD IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SKIN: IRRITATION.
======================= First Aid Measures =======================
First Aid:OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:110F
Lower Limits:0.8%
Extinguishing Media:CO2, DRY CHEMICAL
Fire Fighting Procedures:TREAT AS FUEL FIRE.
Unusual Fire/Explosion Hazard:COMBUSTIBLE.
================== Accidental Release Measures ==================
Spill Release Procedures:KEEP AWAY FROM IGNITION SOURCES. DIKE SPILLS
W/SAND BAGS OR EARTH.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS, & OPEN
FLAME.
Other Precautions:ALWAYS READ LABEL & FOLLOW DIRECTIONS CAREFULLY. KEEP
AWAY FROM CHILDREN.
============= Exposure Controls/Personal Protection =============
Other Protective Equipment:LONG SLEEVED SHIRT & LONG TROUSERS
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:320F
Vapor Pres:12
Spec Gravity:0.95-0.98
Solubility in Water:INSOLUBLE
Appearance and Odor:BLACK SOLVENT
Percent Volatiles by Volume:25-50
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER & OXIDIZING MATERIALS
Stability Condition to Avoid:HEAT, SPARKS, & OPEN FLAME
==================== Disposal Considerations ====================
Waste Disposal Methods:FOLLOW ALL FEDERAL, STATE, & LOCAL REGULATIONS.
COMBUSTIBLE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:66761 CRYSTAL VIOLET
CAGE:0B0Y1
CAGE:0B0Y1
============= Composition/Information on Ingredients =============
Ingred Name:CRYSTAL VIOLET:
(4-(BIS(P-(DIMETHYLAMINO)PHENYL)METHYLENE)-2,5-CYCLOHEXADIEN-1-XLID
ENE)DIMETHYL-AMMONIUM CHLORIDE
CAS:548-62-9
RTECS #:BO9000000
Fraction by Wt: 0.4%
Ingred Name:ETHYL ALCOHOL (ETHANOL)
CAS:64-17-5
RTECS #:KQ6300000
Fraction by Wt: 12%
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM; 9192
Ingred Name:AMMONIUM OXALATE
CAS:1113-38-8
RTECS #:RO2750000
Fraction by Wt: 0.8%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PRODUCT IS IRRITATING TO MUCOUS
MEMBRANES AND MILDLY TOXIC.
Effects of Overexposure:EYE:SEVERE IRRITATION.
INHALED:DROWSINESS,NAUSEA. INGESTION:G/I IRRITATION,NAUSEA,POSSIBLE
BLINDNESS.
Medical Cond Aggravated by Exposure:NONE
======================= First Aid Measures =======================
First Aid:EYE:FLUSH WITH WATER 15 MIN. SKIN:WASH WITH SOAP & WATER.
INHALED:REMOVE TO FRESH AIR. INGESTED:DRINK QUANTITIES OF MILK OR
WATER. INDUCE VOMITING. FOR EYE CONTACT,INHALED,INGESTED,GET
MEDICAL ATTENTI ON.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:48F/9C
Extinguishing Media:DRY CHEMICAL,CARBON DIOXIDE,WATER,SPRAY,FOAM
Fire Fighting Procedures:WEAR SELF CONTAINED BREATHING APPARATUS
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:WIPE UP WITH PAPER TOWELS.
Neutralizing Agent:NONE
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY AREA,AWAY FROM
EXCESSIVE HEAT AND IGNITION SOURCES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NORMALLY NEEDED. USE NIOSH RESPIRATOR FOR
ORGANIC VAPORS/MISTS SHOULD EXPOSURE EXCEED TLV.
Ventilation:USE LOCAL EXHAUST (HOOD) TO MAINTAIN EXPOSURE BELOW TLV.
Work Hygienic Practices:USE GOOD CHEMICAL HYGIENE PRACTICE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F3
Appearance and Odor:PURPLE LIQUID,PUNGENT ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE REPORTED
Stability Condition to Avoid:NONE REPORTED
Hazardous Decomposition Products:NONE REPORTED.HMIS:EXPECT NORMAL
PRODUCTS OF COMBUSTION
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE I/A/W FEDERAL,STATE,LOCAL REGULATIONS
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:STYRENE, 99+%, 24086-9
CAGE:60928
CAGE:60928
============= Composition/Information on Ingredients =============
Ingred Name:STYRENE
CAS:100-42-5
RTECS #:WL3675000
Fraction by Wt: 99%+
OSHA PEL:100 PPM
ACGIH TLV:S,50PPM/100STEL;9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(ORAL RAT) 5 G/KG.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:HARMFUL IF SWALLOWED, INHALED OR
ABSORBED THROUGH SKIN. VAPOR OR MIST IS IRRITATING TO THE EYES,
MUCOUS MEMBRANES AND UPPER RESPIRATORY TRACT. CAUSES SKIN
IRRITATION. EXPOSURE CAN CAUSE NAUSEA, VOMITING, HEADACHE, CNS
DEPRESSION, DERMATITIS. CHRONIC:CARCINOGEN. MAY ALTER GENETIC
MATERIAL. THE (EFTS OF OVEREXP)
Explanation of Carcinogenicity:STYRENE:GROUP 2B (IARC).
Effects of Overexposure:HLTH HAZ:CHEMICAL, PHYSICAL, AND TOXICOLOGICAL
PROPERTIES HAVE NOT BEEN THOROUGHLY INVESTIGATED. TARGET
ORGANS:CENTRAL NERVOUS SYSYTEM.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:SKIN:IMMEDIATELY FLUSH WITH COPIOUS AMOUNTS OF WATER FOR AT
LEAST 15 MINUTES WHILE REMOVING CONTAMINATED CLOTHING AND SHOES.
WASH CONTAMINATED CLOTHING BEFORE REUSE. EYE:FLUSH WITH COPIOUS
AMOUNTS OFWATER FOR AT LEAST 15 MINUTES. INHAL:MOVE TO FRESH AIR.
IF NOT BREATHING GIVE ARTIFICIAL RESPIRATION. IF BREATHING
DIFFICULT GIVE OXYGEN. INGEST:WASH OUT MOUTH W/WATER IF PERSON
CONSCIOUS. CALL MD.
===================== Fire Fighting Measures =====================
Flash Point:88.0F,31.1C
Lower Limits:1.1%
Upper Limits:6.1%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL POWDER OR APPROPRIATE
FOAM.WATER MAY BE INEFFECTIVE FOR COOLING, BUT MAY NOT EFFECT
EXTING.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT. PREVENT CONTACT WITH SKIN AND EYES.
FLAMMABLE. USE WATER SPRAY TO COOL FIRE EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:VAPOR MAY TRAVEL CONSIDERABLE DISTANCE TO
SOURCE OF IGNITION AND FLASH BACK. CONTAINER EXPLOSION MAY OCCUR
UNDER FIRE CONDITIONS. FORMS EXPLO MIXTURES IN AIR.
================== Accidental Release Measures ==================
Spill Release Procedures:EVAC AREA. SHUT OFF ALL IGNIT SOURCES. WEAR
W/ACTIVATED CARBON ABSORBENT, TAKE UP & PLACE IN CLSD CNTNRS,
TRANSPORT OUTDOORS. VENT A REA & WASH SPILL SITE AFTER MATL
PICKUPCOMPLETE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:LIGHT SENSITIVE. KEEP AWAY FROM HEAT,
SPARKS, AND OPEN FLAME. KEEP TIGHTLY CLOSED. REFRIGERATE.
Other Precautions:USE NON SPARKING TOOLS. DO NOT BREATHE VAPOR. AVOID
CONTACT WITH SKIN, EYES AND CLOTHING. READILY ABSORBED THROUGH
SKIN. TOXIC. IRRITANT. CARCINOGEN. MUTAGEN. LACHRYMATOR. KEEP AWAY
FROM IGNITION SOUR CES. NO SMOKING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR APPROPRIATE NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:USE ONLY IN A CHEMICAL FUME HOOD.
Other Protective Equipment:SAFETY SHOWER AND EYE BATH.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
VAP PRESS:4.3 @ 15C. 12.4 @ 37.7C.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:293F,145C
Melt/Freeze Pt:M.P/F.P Text:-24F,-31C
Vapor Pres:SUPDAT
Vapor Density:3.6
Spec Gravity:0.909
Appearance and Odor:COLORLESS LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS, COPPER, COPPER ALLOYS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:TOXIC FUMES OF CARBON MONOXIDE, CARBON
DIOXIDE.
Conditions to Avoid Polymerization:CAN POLYMERIZE ON EXPOUSRE TO LIGHT.
==================== Disposal Considerations ====================
Waste Disposal Methods:BURN IN A CHEMICAL INCINERATOR EQUIPPED WITH AN
AFTERBURNER AND SCRUBBER BUT EXERT EXTRA CARE IN IGNITING AS
MATERIAL IS HIGHLY FLAMMABLE. DIPSOSE OF IN ACCORDANCE WITH LOCAL,
STATE AND FEDERAL REGULA TIONS .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PRINT KOTE CONFORMAL COATING, 22-245
Preparer's Name:M. WINSEL
CAGE:EO177
CAGE:72653
CAGE:EO177
============= Composition/Information on Ingredients =============
Ingred Name:SILICONE RESIN (CONTAINING INGREDIENT 2)
Fraction by Wt: 18%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:BENZENE (SARA 313) (CERCLA)
CAS:71-43-2
RTECS #:CY1400000
Fraction by Wt: 0.005%
OSHA PEL:N/K
ACGIH TLV:10 PPM
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:TOLUENE (SARA 313) (CERCLA)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 52%
OSHA PEL:200 PPM
ACGIH TLV:50 PPM, S
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:PROPANE, 2-METHYL-; (ISOBUTANE)
CAS:75-28-5
RTECS #:TZ4300000
Fraction by Wt: 30%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PROPANE; (PROPANE PROPELLANT)
CAS:74-98-6
RTECS #:TX2275000
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ANESTHESIA, HEADACHE, DIZZINESS,
NAUSEA, EYE IRRITATION, DRYING OF SKIN. CHRONIC: TOLUENE APPEARS ON
THE NAVY LISTING OF OCCUPATIONAL CHEMICAL REPRODUCTIVE HAZARDS.
SEEK CONSULTATION FROM APPROPRIATEHEALTH PROFESSIONALS CONCERNING
LATEST HAZARD LIST INFORMATION AND SAFE HANDLING AND EXPOSURE (EFTS
OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: INFORMATION . THIS PRODUCT CONTAINS A
CHEMICAL KNOWN TO THE STATE OF CALIFORNIA TO CAUSE CANCER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR AT LEAST 15 MINUTES. CONSULT MD.
SKIN: WASH WITH SOAP AND WATER. REMOVE CONTAMINATED CLOTHING AND
LAUNDER BEFORE REUSE. INHALATION: FRESH AIR, OXYGEN, ARTIFICIAL
RESPIRATION IF NECESSARY. INGESTION: DO NOT INDUCEVOMITING. SLOW
DILUTE WITH 1-2 GLASSES OF WATER OR MILK AND SEEK MEDICAL
ATTENTION. NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point Method:OC
Extinguishing Media:CARBON DIOXIDE, CHEMICAL FOAM.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . TOXIC FUMES WILL BE FORMED UPON COMBUSTION.
Unusual Fire/Explosion Hazard:CAN BURST IF EXPOSED TO TEMPERATURES
ABOVE 120F.
================== Accidental Release Measures ==================
Spill Release Procedures:PICK UP WITH AN INERT ABSORBENT MATERIAL.
STORE IN SEALED METAL CONTAINERS FOR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID HIGH TEMPERATURES AND IGNITION
SOURCES. STORE IN A COOL, VENTILATED AREA.
Other Precautions:AVOID INHALATION AND REPEATED OR PROLONGED SKIN
CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED RESPIRATORY PROTECTION IF TLV IS
EXCEEDED.
Ventilation:LOCAL EXHAUST. MECHANICAL AS REQUIRED TO MEET TLV.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:AEROSOL
Vapor Pres:75 PSI
Vapor Density:>1
Spec Gravity:0.86
VOC Pounds/Gallon:447
Evaporation Rate & Reference:1.5
Solubility in Water:NOT SOLUBLE
Appearance and Odor:CLEAR, COLORLESS; TOLUENE ODOR.
Percent Volatiles by Volume:91
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:HEAT AND IGNITION SOURCES.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
SILICON DIOXIDE AND FORMALDEHYDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:LICENSED INCINERATION OR PER FEDERAL, STATE AND
LOCAL GOVERNMENT REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:THERMIC TORCH
CAGE:IO583
CAGE:0SAH3
CAGE:IO583
============= Composition/Information on Ingredients =============
Ingred Name:IRON
CAS:7439-89-6
RTECS #:NO4565500
Fraction by Wt: <99%
OSHA PEL:10 MG/M3 (MFR)
ACGIH TLV:5 MG/M3 (MFR)
Ingred Name:CARBON; % WEIGHT: 0.08-0.18
CAS:7440-44-0
RTECS #:FF5250100
Fraction by Wt: <0.18%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:2 MG/M3 TDUST
Ingred Name:MANGANESE (SARA 313)
CAS:7439-96-5
RTECS #:OO9275000
Fraction by Wt: 0.3-0.6%
OSHA PEL:C 5 MG/M3 DUST
ACGIH TLV:5 MG/M3 DUST
Ingred Name:PHOSPHOROUS (YELLOW) (SARA 302/313) (CERCLA) % WEIGHT:
0.015-0.035
CAS:7723-14-0
RTECS #:TH3500000
Fraction by Wt: <0.035%
OSHA PEL:0.1 MG/M3
ACGIH TLV:0.02 PPM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SULFUR
CAS:7704-34-9
RTECS #:WS4250000
Fraction by Wt: <0.02%
OSHA PEL:13 MG/M3 (MFR)
ACGIH TLV:5.2 MG/M3 (MFR)
Ingred Name:SILICON
CAS:7440-21-3
RTECS #:VW0400000
Fraction by Wt: <0.02%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:ALUMINUM (SARA 313) % WEIGHT: 0.02-0.07
CAS:7429-90-5
RTECS #:BD0330000
Fraction by Wt: <0.07%
OSHA PEL:15 MG/M3 DUST
ACGIH TLV:10 MG/M3 DUST
Ingred Name:COPPER (SARA 313) (CERCLA)
CAS:7440-50-8
RTECS #:GL5325000
Fraction by Wt: <0.10%
OSHA PEL:0.1MG/M3 FUME/1 DUST
ACGIH TLV:0.2 MG/M3 FUME
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:NICKEL (SARA 313) (CERCLA)
CAS:7440-02-0
RTECS #:QR5950000
Fraction by Wt: <0.06%
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3
Ingred Name:CHROMIUM (SARA 313) (CERCLA)
CAS:7440-47-3
RTECS #:GB4200000
Fraction by Wt: <0.05%
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:MOLYBDENUM
CAS:7439-98-7
RTECS #:QA4680000
Fraction by Wt: <0.05%
OSHA PEL:10 PPM
ACGIH TLV:10 PPM
Ingred Name:ZINC (SARA 313) (CERCLA)
CAS:7440-66-6
RTECS #:ZG8600000
Fraction by Wt: 0.7-6.0%
OSHA PEL:5 MG/MR (MFR) (FUME)
ACGIH TLV:5 MG/M3 (MFR) (FUME)
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES/SKIN: LOC IRRIT. INHAL:
EXCESS EXPOS TO FUME MAY CAUSE SWEET/METALLIC TASTE IN MOUTH, IMMED
DRYNESS & IRRIT OF THROAT, TIGHTNESS OF CHEST & COUGHING. SEVERAL
HRS LATER, SYMPS MAY PROGRESS TO FEVER, MALAISE, PERSPIRATION,
FRONTAL HDCH, MUSCLE CRAMPS, LOW BACK PAIN, OCCAS BLURRED VISION,
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: NAUS & VOMIT. PULM CONGESTION,
SHORTNESS OF BREATH & SYMPS OF OXYGEN DEFICIENCT MAY ALSO DEVELOP.
INGEST: NAUS, VOMIT & PURGING. EXPOS TO UV RADIA CAN RSLT IN
KERATOCONJUNCTIVITIS, ALSO KNOW N AS WELDERS FLASH. SYMPS INCL
INFLAMM,BLURRED VISION & HDCH. CHRONIC: SKIN: PRLNG CHRONIC/RPTD
CONT W/ZINC (SUP DAT)
Medical Cond Aggravated by Exposure:RESPIRATORY ILLNESS/DISEASES,
NEUROLOGICAL AND SKIN DISORDERS/DISEASES.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/RUNNING WATER, INCL UNDER EYELIDS, FOR AT LEAST
15 MIN. IF IRRIT PERSISTS, SEEK MED ATTN. SKIN: CONTAM SHOES &
CLTHG SHOULD BE REMOVED & AFFECTED AREA WASHED W/SOAP & WATER.
INHAL: REMOV E TO FRESH AIR IMMED. IF BRTHG HAS STOPPED, GIVE ARTF
RESP. KEEP WARM & AT REST. SEEK MED ATTN IMMED. INGEST: IF
CONSCIOUS DILUTE STOM, INDUCE VOMIT. QUALIFIED MED PERS SHOULD
REMOVE (SUP DAT)
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:NOT APPLICABLE. USE MEDIA SUITABLE FOR SURROUNDING
FIRE .
Fire Fighting Procedures:NOT APPLICABLE. WEAR NIOSH APPROVED SCBA AND
FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:OIL AND GREASE ON TORCHES CAN CAUSE A
VIOLENT REACTION IN THE PRESENCE OF OXYGEN.
================== Accidental Release Measures ==================
Spill Release Procedures:NOT APPLICABLE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:WARNING - KEEP AWAY FROM OIL AND
GREASE.
Other Precautions:OTHER HAZARDS CAN BE CREATED BASED ON MATERIAL BEING
CUT (E.G., VAPORS RELEASED FROM RESIDUE WHILE CUTTING).
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED AIR PURIFYING RESPIRATOR IF AREA
IS UNVENTILATED AND LOCAL EXHAUST NOT AVAILABLE.
Ventilation:LOCAL EXHAUST: USE IN ENCLOSED AREA. WELL-VENTILATED AREA.
Other Protective Equipment:ANSI APPROVED EMERGENCY EYEWASH AND DELUGE
SHOWER . HARD HAT, LEATHER OR FIRE RETARDANT PROTECTIVE CLOTHING.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EFTS OF OVEREXP: DUST/POWDER MAY CAUSE MILD DERM. INHAL: RPTD OVEREXP
MAY CAUSE PRLNG FORMS OF METAL FUME FEVER. FIRST AID PROC:
REMAINING CHEMS BY GASTRIC LAVAGE. SEEK MED ATTN IMMED.
================== Physical/Chemical Properties ==================
Solubility in Water:INSOLUBLE
Appearance and Odor:TUBULAR STEEL; NO NOTICEABLE ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OIL AND GREASE ON TORCH CAN CAUSE A VIOLENT REACTION IN THE PRESENCE OF
UNBURNED OXYGEN.
Stability Condition to Avoid:ALLOWING GASES TO BE TRAPPED IN A CONFINED
AREA.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:COMPLY WITH ALL LOCAL, STATE AND FEDERAL
REGULATIONS FOR PROPER DISPOSAL.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:98-26 RED IRON OXIDE SPRUCE 473
CAGE:59581
CAGE:59581
============= Composition/Information on Ingredients =============
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 14-16%
Other REC Limits:100 PPM
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:VM&P NAPHTHA (LIGROINE)
CAS:8032-32-4
RTECS #:OI6180000
Other REC Limits:STEL 400 PPM
OSHA PEL:300 PPM/400 STEL
ACGIH TLV:300 PPM; 9192
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 11-14%
Other REC Limits:100 PPM
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:HEXANE (N-HEXANE)
CAS:110-54-3
RTECS #:MN9275000
Other REC Limits:50 PPM
OSHA PEL:500 PPM
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:ACETONE (SARA III)
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 24-27%
Other REC Limits:590 MG/CUM
OSHA PEL:1000PPM
ACGIH TLV:750PPM/1000STEL;9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Other REC Limits:1800 MG/CUM
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT; 9192
Ingred Name:ISOBUTANE, 2-METHYLPROPANE
CAS:75-28-5
RTECS #:TZ4300000
Other REC Limits:1000 PPM
OSHA PEL:1800 MG/CUM
ACGIH TLV:1000 PPM
Ingred Name:ALUMINUM (SARA III)
CAS:7429-90-5
RTECS #:BD0330000
Fraction by Wt: 1-3%
OSHA PEL:15MG/M3 DUST/5 FUME
ACGIH TLV:10MG/M3 DUST; 9192
Ingred Name:MINERAL SPIRITS
Ingred Name:ETHYL ALCOHOL (ETHANOL)
CAS:64-17-5
RTECS #:KQ6300000
Other REC Limits:1900 MG/CUM
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM; 9192
Ingred Name:MODIFIED SHORT OIL ALKYD
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: IRRITANT. SKIN:
DEFATTING/DERMATITIS/SCALY/REDNESS/DRY/ABSORPTION. INHALATION:
RESPIRATORY SYSTEM IRRITATION/HEADACHE/DIZZINESS/NAUSEA/POSSIBLE
UNCONSCIOUSNESS/ASPHYXIATION/NOSE/THROAT IRRITATION
/NAUSEA/VOMITING/INCOORDINATION/DROWSINESS. INGESTION:
STUPER/INTOXICATION/COMA.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: CARDIAC EFFECTS/CNS
DEPRESSION/PERIPHERAL POLYNEUROPATHY/COMA/NARCOSIS/CUMULATIVE
NARCOTIC EFFECTS/ACIDOSIS/HARMFUL/FATAL. INGESTION:
BLINDNESS/FATAL. EYES: PERMANENT LOSS OF VISION. SKIN: FISSURED
DERMATITIS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. IF BREATHING STOPS, BEGIN
ARTIFICIAL RESPIRATION. EYES: FLUSH W/WATER FOR 15 MINUTES. SKIN:
WASH W/SOAP & WATER. INGESTION: UNLIKELY FROM AN AEROSOL CAN.
OBTAIN MEDICA L ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TOC
Flash Point:-10F
Lower Limits:0.70%
Upper Limits:9.5%
Extinguishing Media:USE CO2, DRY CHEMICAL & FOAM
Fire Fighting Procedures:WATER SPRAY MAY BE INEFFECTIVE. IF WATER IS
KEEP FIRE-EXPOSED CONTAINERS COOL.
Unusual Fire/Explosion Hazard:EXPOSURE TO HEAT OR SUN MAY CAUSE
BURSTING.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. WIPE UP W/INERT MATERIALS &
PLACE IN APPROPRIATE CONTAINER.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T STORE >120F. EXPOSURE TO HEAT OR
PROLONGED EXPOSURE TO SUN MAY CAUSE BURSTING.
Other Precautions:INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING
VAPORS & INHALING CONTENTS CAN BE HARMFUL OR FATAL. USE ONLY AS
DIRECTED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE A SELF-CONTAINED BREATHING APPARATUS
REQUIRED FOR CONCENTRATIONS >TLV.
Ventilation:ADEQUATE VENTILATION IS SUFFICIENT.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Vapor Pres:40 PSIA
Vapor Density:>AIR
Evaporation Rate & Reference:FASTER THAN ETHER
Solubility in Water:INSOLUBLE
Appearance and Odor:PAINT W/SOLVENT ODOR
Percent Volatiles by Volume: 85%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS & STRONG OXIDIZING AGENTS
Stability Condition to Avoid:TEMPS >120F, SPARKS, PILOT LIGHT, OPEN
FLAME, SOURCES OF IGNITION, HEAT & SUNLIGHT
Hazardous Decomposition Products:CO2 & CO
==================== Disposal Considerations ====================
Waste Disposal Methods:DON'T INCINERATE AEROSOL CAN, DISPOSE OF IN
ACCORDANCE W/LOCAL STATE & FEDERAL REGULATIONS. DON'T PLACE AEROSOL
CANS IN HOME COMPACTOR. DON'T PUNCTURE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:3-CHLOROBENZYL CHLORIDE 98% 82867 AC151700250
CAGE:1B464
CAGE:1B464
============= Composition/Information on Ingredients =============
Ingred Name:3-CHLOROBENZYL CHLORIDE
CAS:620-20-2
= Wt:98.
===================== Hazards Identification =====================
Health Hazards Acute and Chronic:LACHRYMATOR.
Effects of Overexposure:LACHRYMATOR.
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH W/PLENTY OF WATER FOR 15 MINS. SKIN:
FLUSH W/PLENTY OF SOAP & WATER FOR 15 MINS. INGESTION: DON'T INDUCE
VOMITING. RINSE MOUTH & THEN GIVE TO DRINK 2-4 CUPFULS OF WATER.
INHALA TION: REMOVE TO FRESH AIR IMMEDIATELY. OBTAIN MEDICAL
ATTENTION IN ALL CASES. NOTES TO PHYSICIAN: TREAT SYMPTOMATICALLY &
SUPPORTIVELY.
===================== Fire Fighting Measures =====================
Flash Point:=98.C, 208.4F
Extinguishing Media:DON'T USE WATER DIRECTLY ON FIRE. USE FOAM, DRY
CHEMICAL/CO2
Fire Fighting Procedures:WEAR A SELF CONTAINED BREATHING APPARATUS IN
PRESSURE-DEMAND, MSHA/NIOSH APPROVED & FULL PROTECTIVE GEAR.
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTIVE EQUIPMENT.
ABSORB W/INERT MATERIAL; DRY SAND/EARTH, THEN PLACE INTO A CHEMICAL
WASTE CONTAINER.
======================Handling and Storage ======================
Other Precautions:PREVENT SKIN EXPOSURE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR A NIOSH/MSHA APPROVED FULL-FACEPIECE
AIRLINE RESPIRATOR IN THE POSITIVE PRESSURE MODE W/EMERGENCY ESCAPE
PROVISIONS.
Ventilation:ADEQUATE GENERAL/LOCAL EXHAUST TO KEEP AIRBORNE
CONCENTRATIONS BELOW THE PEL.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING & SHOES
BEFORE REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:419-420.8F
Spec Gravity:1.27
Solubility in Water:IMMISCIBLE
Appearance and Odor:CLEAR, COLORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
BASES, AMINES, OXIDIZING AGENTS, ALCOHOLS, STEEL
Stability Condition to Avoid:MOISTURE
Hazardous Decomposition Products:HYDROGEN CHLORIDE, CO, CO2
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:US DOT SHIPPING NAME: CHLOROBENZYLCHLORIDES UN
NUMBER 2235 PACKING GROUP III.
===================== Regulatory Information =====================
Federal Regulatory Information:TSCA CAS# 620-20-2 IS LISTED ON THE TSCA
INVENTORY.
State Regulatory Information:RISK PHRASES: R20/21/22: HARMFUL BY
INHALATION, IN CONTACT W/SKIN & IF SWALLOWED. R36 IRRITATING TO
EYES. R43 MAY CAUSE SENSITIZATION BY SKIN CONTACT. R51/53 TOXIC TO
AQUATIC ORGANISMS; MAY CAUSE LON G-TERM ADVERSE EFFECTS IN THE
AQUATIC ENVIRONMENT. SAFETY PHARASES: S26 IN CASE OF CONTACT
W/EYES, RINSE IMMEDIATELY W/PLENTY OF WATER & SEEK MEDICAL ADVICE.
PROTECTION. S14C KEEP AWAY FROM WATER, ACIDS & ALKALI. S61 AVOID
RELEASE TO TH E ENVIRONMENT. REFER TO SPECIAL INSTRUCTIONS/SAFETY
DATA SHEETS.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:DEOXIDIZING TUBES PC
Preparer's Name:TREVOR HARDY
CAGE:2W462
CAGE:2W462
============= Composition/Information on Ingredients =============
Ingred Name:NO INGREDIENT FOR THIS FORMULATION_INGREDIENT
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:NONE WHEN TUBES ARE INTACT.
CONTENTS MAY CAUSE SKIN, EYE AND UPPER RESPIRATORY TRACT
IRRITATION. CHRONIC:NONE WHEN TUBES ARE INTACT. NIOSH LISTS
RESPIRATORY SYSTEM, SKIN, LIVER, KIDNEYS AS TARGE T ORGANS FOR
COPPER DUSTS AND MISTS.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SKIN IRRITATION OR RASH.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN AILMENTS.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. SKIN:WASH WITH WATER. EYE:FLUSH
WITH WATER FOR AT LEAST 15 MINUTES TO REMOVE PARTICLES. INGEST:CALL
MD IMMEDIATELY .
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WILL NOT BURN. USE MEDIA SUITABLE FOR SURROUNDING
FIRE CONDITIONS .
Fire Fighting Procedures:NOT APPLICABLE. WEAR NIOSH/MSHA APPROVED SCBA
AND FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NOT APPLICABLE.
================== Accidental Release Measures ==================
Spill Release Procedures:RETURN INTACT TUBES TO CONTAINER. SWEEP UP
SPILLED TUBE CONTENTS INTO DRY CONTAINER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN DRY PLACE. DRY AND PREHEAT
BEFORE USE; DO NOT EXCEED 350F IN PREHEAT.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED, BUT IF PEL/TLV IS
EXCEEDED USE NIOSH/MSHA APPROVED DUST MASK.
Ventilation:RECOMMENDED SUFFICIENT TO MAINTAIN BELOW PEL/TLV.
Other Protective Equipment:NOT APPLICABLE.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:7.5
Appearance and Odor:COPPER TUBE-NO ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS AND ALKALIES.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WTIH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:G641 SILICONE COMPOUND
Preparer's Name:DA POLSINELLI
CAGE:FO099
CAGE:FO099
CAGE:01139
============= Composition/Information on Ingredients =============
Ingred Name:ZINC OXIDE
CAS:1314-13-2
RTECS #:ZH4810000
Fraction by Wt: 60-80%
OSHA PEL:5 MG/CUM
ACGIH TLV:5 MG/CUM FUME
Ingred Name:DIMETHYL POLYSILOXANE (MONOMER: DIMETHYL SILOXANE),
SILICONE FLUID, DOW CORNING 200, POLYMETHYLSILOXANE
CAS:63148-62-9
RTECS #:JT6484500
Fraction by Wt: 10-30%
Ingred Name:VOL ORGANIC CMPD: <5 G/L
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: MODERATE IRRITATION. SKIN: MAY
CAUSE MILD IRRITATION. SUBCHRONIC EFFECT: METAL FUME FEVER.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION
======================= First Aid Measures =======================
First Aid:INGESTION: RINSE MOUTH W/WATER SEVERAL TIMES. SKIN: WASH
W/SOAP & WATER. INHALATION: MOVE TO FRESH AIR. EYES: IMMEDIATELY
FLUSH W/PLENTY OF WATER FOR 15 MINS. OBTAIN MEDICAL ATTENTION IN
ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:>500F
Extinguishing Media:ALL STANDARD FIREFIGHTING MEDIA
================== Accidental Release Measures ==================
Spill Release Procedures:WIPE/SCRAPE/SOAK UP IN AN INERT MATERIAL & PUT
IN A CONTAINER FOR DISPOSAL. WASH WALKING SURFACES W/DETERGENT &
WATER TO REDUCE SLIPPING HAZARD. WEAR PROPER PROTECTIVE EQUIPMENT.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTACT W/EYES.
Other Precautions:THIS PRODUCT CONTAINS METHYLPOLYSILOXANES WHICH CAN
GENERATE FORMALDEHYDE AT 300F & ABOVE, IN ATMOSPHERES CONTAINING
OXYGEN. FORMALDEHYDE IS A SKIN, RESPIRATORY SENSITIZER, EYE, THROAT
IRRITANT, ACUT E TOXICANT & POTENTIAL CANCER HAZARD.
============= Exposure Controls/Personal Protection =============
Other Protective Equipment:EYEWASH STATIONS
Supplemental Safety and Health
SOLUBILITY IN ORGANIC SOLVENT: SOLUBLE TOLUENE.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>600F
Vapor Pres:<1
Vapor Density:NEGLIGIBLE
Spec Gravity:2.6
Evaporation Rate & Reference:(BU AC=1): NEGLIGIBLE
Solubility in Water:INSOLUBLE
Appearance and Odor:WHITE SOLID, ODORLESS.
Percent Volatiles by Volume:<1
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS
Stability Condition to Avoid:TEMP 300F
Hazardous Decomposition Products:CO/CO2/FORMALDEHYDE/SILICON DIOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:BUCKEYE SHOPMASTER
CAGE:85140
CAGE:85140
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: >74%
Other REC Limits:NONE RECOMMENDED
Ingred Name:PROPYLENE GLYCOL PHENYL ETHER
CAS:770-35-4
Fraction by Wt: <10%
Other REC Limits:NONE RECOMMENDED
Ingred Name:TRIPROPYLENE GLYCOL METHYL ETHER
CAS:10213-77-1
RTECS #:UB8050000
Fraction by Wt: <5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM METASILICATE
CAS:6834-92-0
RTECS #:VV9275000
Fraction by Wt: <3%
Other REC Limits:NONE RECOMMENDED
Ingred Name:ISODECYLOXYPROPYLAMINODIPHROPIONIC ACID MONOSODIUM SALT
CAS:64972-19-6
Fraction by Wt: <3%
Other REC Limits:NONE RECOMMENDED
Ingred Name:PERFUME COLORING AND ADDITIVES LESS THAN 1%
Fraction by Wt: <5%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SLIGHT EYE IRRITANT. NOT IRRITATING TO
SKIN. NOT TOXIC BY INGESTION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:FOR EYES: REDNESS OR BURNING SENSATION.
Medical Cond Aggravated by Exposure:DERMATITIS
======================= First Aid Measures =======================
First Aid:FOR EYES-FLUSH WITH COOL WATER FOR 15 MINUTES. IF IRRITATION
PERSISTS SEE PHYSICIAN. FOR SKIN-WASH WITH SOAP AND WATER. IF
IRRITATION OCCURS AND PERSISTS, SEE PHYSICIAN. FOR INGESTION-GIVE
TWO LARGE G LASSES OF WATER. DO NOT INDUCE VOMITING. CALL
PHYSICIAN. NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:NONE
Extinguishing Media:NONE SPECIFIED BY MANUFACTURER.
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:PRODUCTS OF COMBUSTION, OXIDES OF CARBON
AND SILICON.
================== Accidental Release Measures ==================
Spill Release Procedures:PICK UP W/MOP, WET/DRY OR ABSORBENT MATERIAL.
RINSE AREA W/CLEAR WATER & ALLOW FLOOR TO DRY BEFORE ALLOWING
TRAFFIC THRU.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AT ROOM TEMPERATURE. KEEP
CONTAINER CLOSED WHEN NOT IN USE. IF CONCENTRATED OR DILUTED
PRODUCT IS ALLOWED TO DRY ON GLASS, ETCHING MAY OCCUR.
Other Precautions:KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED.
Ventilation:NORMAL ROOM VENTILATION.
Other Protective Equipment:FOOTWEAR THAT KEEP FEETS DRY IS SUGGESTED.
Work Hygienic Practices:FOLLOW GOOD PERSONAL HYGIENE PRACTICES.
Supplemental Safety and Health
NONE.
================== Physical/Chemical Properties ==================
HCC:B3
Boiling Pt:B.P. Text:212F,100C
Spec Gravity:1.03
pH:11.5
Evaporation Rate & Reference:(WATER = 1): 1
Appearance and Odor:FLORAL, CLEAR YELLOW SOLUTION.
Percent Volatiles by Volume:95/WT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
DO NOT MIX WITH CHLORINE BLEACH.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:NONE KNOWN.
==================== Disposal Considerations ====================
Waste Disposal Methods:DILUTE W/WATER & ADJUST PH W/ACID TO PH BELOW 9,
THEN FLUSH TO SANITARY SEWER OR SEND TO SANITARY LANDFILL FOLLOWING
LOCAL, STATE AND FEDERAL LAWS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CREST PAINT STRIPPER #7
Preparer's Name:J.D. BENNETT
CAGE:77513
CAGE:77513
============= Composition/Information on Ingredients =============
Ingred Name:METHYLENE CHLORIDE (SARA 313) (CERCLA)
CAS:75-09-2
RTECS #:PA8050000
Fraction by Wt: >36%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:500 PPM
ACGIH TLV:50 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:PHENOL (SARA 302/313) (CERCLA)
CAS:108-95-2
RTECS #:SJ3327000
Fraction by Wt: >16%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 PPM
ACGIH TLV:5 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SODIUM CHROMATE (SARA 313) (CERCLA)
CAS:7775-11-3
RTECS #:GB2955000
Fraction by Wt: >1.8%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.1 PPM
ACGIH TLV:0.05 PPM
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
===================== Hazards Identification =====================
Reports of Carcinogenicity:NTP:UNKNOWN IARC:YES
Health Hazards Acute and Chronic:EXCESSIVE AMOUNTS MAY CAUSE COLLAPSE &
DAMAGE TO HEART. INHALATION: IN CONFINED OR POORLY VENTILATED
AREAS, VAPORS CAN CAUSE UNCONSCIOUSNESS. HIGH LEVELS OVER 1000 PPM
CAN CAUSE UNCONSCIOUSNESS. THESE HIGH LEVELS MAY ALSO CAUSE
CARDIAC ARRYTHMIAS. EXCESSIVE EXPOSURE MAY CAUSE IRRITATION TO THE
UPPER RESPIRATORY TRACT.
Explanation of Carcinogenicity:METHYLENE CHLORIDE LISTED AS POTENTIAL
CARCINOGEN,NOT BELIEVED TO POSE MEASURABLE RISK WHEN HANDLED AS
RECOMMENDED.
Effects of Overexposure:EXCESSIVE EXPOSURE MAY CAUSE CENTRAL NERVOUS
SYSTEM EFFECTS
(GIDDINESS,HEADACHE,DIZZINESS,NAUSEA,UNCONSCIOUSNESS,DEATH),CARBOXY
HEMOGLOBINEMIS (IMPAIRING BLOOD'S ABILITY TO TRANSPORT
OXYGEN).KIDNEY DAM AGE (CHANGE IN URINE OUTPUT).LIVER DAMAGE
(APPETITE LOSS,JAUNDICE PAIN IN UPPER RIGHT ABDOM) HEART DAMAGE
(SHORT BREATH)
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN, EYE, AND
RESPIRATORY DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS
PRODUCT. IMPAIRED KIDNEY, LIVER, HEART FUNCTIONS FROM PRE-EXISTING
DISORDERS MAY BE AGGRAVATED BY EXPOSURE.
======================= First Aid Measures =======================
First Aid:EYE:IMMED FLUSH W/WATER AT LEAST 15 MIN.GET MED AID
IMMED.VAPOR MAY BE IRRITATING. SKIN:IMMED FLUSH WITH WATER 15 MIN.
INHALATION:REMOVE TO FRESH AIR & GIVE OXYGEN IF BREATHING
DIFFICULT.GIVE ARTIF RE SPIRATION IF NOT BREATHING.GET MED AID
IMMED. INGESTION:DON'T INDUCE VOMITING.DON'T GIVE LIQ TO
DROWSY,CONVULSING,UNCONSCIOUS PERSON.GIVE LRG QTY WATER.IF VOMITING
OCCURS,GIVE LRG QTY H2O.GET MED AID.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:NONE TO BOILING
Fire Fighting Procedures:THERMAL DECOMP WILL PRODUCE TOXIC OXIDES OF
CHLORINE & CARBON.DON'T ENTER CONFINED FIRE SPACE W/OUT FULL BUNKER
GEAR W/SCBA.COOL FIRE EXPOSED CONTAINERS W/WATER
Unusual Fire/Explosion Hazard:MAY PRODUCE CARBON & CHLORINE OXIDES.
OXIDES DANGEROUS. COOL CONTAINERS EXPOSED TO HEAT W/WATER. COOL
CONTAINER AREA EXPOSED TO DIRECT FLAME W/LRG AMOUNT WATER
================== Accidental Release Measures ==================
Spill Release Procedures:PREVENT CONTACT W/MAT'L.WEAR RESPIRATOR &
FULL-BODY PROTECTIVE CLOTHING.SPILL MAY BE SLIPPERY;TAKE CARE TO
AVOID FALLING.SHUT OFF AT SOURCE IF SAFE.DIKE & CONTAIN.REMOVE
W/VACUUM TRUCK OR PUMP TO STOR AGE/SALVAGE VESSEL.SOAK UP RESIDUAL
W/ABSORBENT *
Neutralizing Agent:N/K* PLACE IN NON-LEAKING CONTAINER & SEAL
TIGHTLY. FLUSH AREA W/WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T STORE IN DIRECT SUNLIGHT.STORE
<99F BUT NOT <32F.AVOID USE IN UNVENTED AREA.DISCARD
BULGING/DISTORTED CONTAINERS.DON'T RECYCLE/REUSE CONTAINER.
Other Precautions:STORE IN COOL, DRY, VENTED AREA. STORE AWAY FROM
OTHER CHEMICALS. KEEP CONTAINER TIGHTLY CLOSED WHEN NOT IN USE. DO
NOT USE PRESSURE TO EMPTY CONTAINER. WASH THOROUGHLY AFTER
HANDLING. DON'T GET ON SK IN, EYES, CLOTHING. CONTENTS MAY BE **
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA BREATHING APPARATUS.ABOVE TLV,NISOH
SCBA POS PRESSR HOSE MASK/AIR LINE MASK.FULL FACE SHIELD
OPERATED-POS PRESSR.LIMITED EXPOSURE,FULL FACE MASK W/ORGANIC
CARTRIDGE/CANISTER (NOT IN LOW LYI NG AREA).FORMAL RESPRTR TRAINING
NEEDED.
Ventilation:LOCAL EXHAUST & MECHANICAL VENT. ** UNDER PRESURE. OPEN
W/CARE TO AVOID INJURY. COVER OPENING. SLOWLY TURN BUNG TO ***
Other Protective Equipment:SOLVENT RESISTANT APRONS, BOOTS, AND SUITS
MUST BE WORN.
Work Hygienic Practices:WASH ALL EXPOSED AREAS W/SOAP & WATER AFTER
USING PRODUCT. DO NOT SMOKE AROUND THIS PRODUCT.
Supplemental Safety and Health
*** BREAK SEAL & RELIEVE INTERNAL PRESSURE. AFTER EQUALIZED, REMOVE
BUNG. IF IN DOUBT, DON'T REMOVE BUNG, SEEK SUPERVISION. DO NOT CUT,
GRIND, OR WELD ON CONTAINER. EVEN THOSE CONTAINERS THAT ARE EMPT Y
WILL RETAIN PRODUCT RESIDUE & VAPOR. OBEY HAZARD WARNINGS & HANDLE
EMPTY CNTNRS AS IF FULL.
================== Physical/Chemical Properties ==================
HCC:T4
Boiling Pt:B.P. Text:110F,43C
Vapor Pres:350
Vapor Density:>1
Spec Gravity:1.13 (H2O=1)
VOC Pounds/Gallon:157
VOC Grams/Liter:1.7
Viscosity:<5000 CPS
Evaporation Rate & Reference:GREATER THAN 1 (BU AC=1)
Solubility in Water:SLIGHTLY SOLUBLE
Appearance and Odor:VISCOUS YELLOW LIQUID WITH A PHENOLIC ODOR
Percent Volatiles by Volume:96
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID STRONG OXIDIZERS
Hazardous Decomposition Products:THERMAL DECOMPOSITION WILL PRODUCE
TOXIC OXIDES OF CARBON & CHLORINE.OXIDIZERS WILL PRODUCE CO2,CO,&
OXIDES OF CHLORINE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE PER STATE, CITY & FEDERAL REGULATIONS.
DO NOT DISPOSE OR DISCHARGE INTO SEWERS OR NAVIGABLE WATERS. DO NOT
ALLOW PRODUCT TO CONTAMINATE GROUND WATERS. DISPOSAL PRACTICE MUST
BE IN COMPLIANCE W ITH FEDERAL, STATE, & LOCAL REGULATIONS.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MIL-V-173 C COMP II CLEAR GLOSS VARNISH M & F RESISTANT
CAGE:00297
CAGE:00297
CAGE:77672
============= Composition/Information on Ingredients =============
Ingred Name:OIL MODIFIED PHENOLIC VARNISH SOLUTION
Fraction by Wt: 50%
Other REC Limits:NONE RECOMMENDED
Ingred Name:N-BUTYL ACETATE (CERCLA)
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: 10%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:150 PPM
ACGIH TLV:150 PPM/200STEL;9495
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA 313) (CERCLA)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:200 PPM
ACGIH TLV:200 PPM/300STEL;9495
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:STODDARD SOLVENT/ALIPHATIC NAPHTHA
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 35%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:500 PPM
ACGIH TLV:100 PPM; 9495
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT) IS NOT KNOWN.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYES, SKIN, CNS, BRAIN.
ACUTE- EXCESSIVE INHALATION IS HARMFUL/FATAL. MAY CAUSE CNS
DEPRESSION. MAY HAVE ANESTHETIC EFFECT. EYE CONTACT MAY CAUSE
IRRITATION. REPEATED SKIN CONTACT MAY CA USE CRACKING & IRRITATION.
HARMFUL IF SWALLOWED. CHRONIC- OVEREXPOSURE MAY CAUSE SKIN RASH,
BLISTERING & CNS EFFECTS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, HEADACHE, DIFFICULTY IN BREATHING,
NAUSEA, VOMITING, SKIN RASH AND BLISTERING
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH PRE-EXISTING
DISEASES OF THE EYE, SKIN, RESPIRATORY TRACT, CNS MAY HAVE
INCREASED SUSCEPTIBILITY TO THE TOXICITY OF EXCESSIVE EXPOSURES.
======================= First Aid Measures =======================
First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALATION:REMOVE TO
FRESH AIR. PROVIDE CPR/OXYGEN IF NEEDED. EYES:FLUSH WITH WATER FOR
15 MINUTES, HOLDING EYELIDS OPEN. SKIN:WASH WITH SOAP & WATER.
INGESTION:D O NOT INDUCE VOMITING. GET MEDICAL ATTENTION
IMMEDIATELY. NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:21.0F,-6.1C
Lower Limits:0.9%
Upper Limits:11.4%
Extinguishing Media:USE FOAM, DRY CHEMICAL OR CARBON DIOXIDE. WATER MAY
BE INEFFECTIVE. WATER STREAM WILL SPREAD FIRE.
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING AND
NIOSH-APPROVED SELF-CONTAINED BREATHING APPARATUS. COOL
FIRE-EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:VAPOR IS HEAVIER THAN AIR AND CAN TRAVEL
CONSIDERABLE DISTANCE TO A SOURCE OF IGNITION AND FLASH BACK.
CONTAINERS MAY RUPTURE DUE TO VAPOR PRESSURE BUILDUP.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. ELIMINATE SOURCES
OF IGNITION. VENTILATE AREA. CONTAIN SPILL. PICK UP SPILL WITH
NON-FLAMMABLE ABSORBENT SUCH AS SAND, EARTH/USE PUMP (EXPLOSION
PROOF). GROUND ALL HANDLING EQUIPMENTS. PREVENT LIQUID FROM
ENTERINGSEWERS.
Neutralizing Agent:NOT RELEVANT
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, VENTILATED AREA, AWAY
FROM HEAT, FLAMES, SPARKS, HOT SURFACES & INCOMPATIBLE MATERIALS.
KEEP CONTAINER TIGHTLY CLOSED.
Other Precautions:"EMPTY" CONTAINERS RETAIN RESIDUE AND MAY BE
DANGEROUS. FOLLOW ALL LABEL INSTRUCTIONS. AVOID REPEATED/PROLONGED
SKIN CONTACT. KEEP OUT OF REACH OF CHILDREN. DO NOT BREATHE VAPORS.
AVOID EYE AND SKIN C ONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF TLV IS EXCEEDED, WEAR NIOSH-APPROVED ORGANIC
VAPOR RESPIRATOR OR AIR-PURIFYING RESPIRATOR. IN EMERGENCY, WEAR A
NIOSH-APPROVED POSITIVE-PRESSURE SELF-CONTAINED BREATHING
APPARATUS.
Ventilation:MECHANICAL (GENERAL AND/OR LOCAL EXHAUST, EXPLOSION-PROOF)
VENTILATION TO MAINTAIN EXPOSURE BELOW TLV(S).
Other Protective Equipment:EYE WASH STATION & SAFETY SHOWERS SHOULD BE
AVAILABLE IN THE IMMEDIATE VICINITY OF ANY POTENTIAL EXPOSURE.
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. WASH THOROUGHLY BEFORE EATING,
DRINKING/SMOKING.
Supplemental Safety and Health
FORMULA CHANGED. FOR PREVIOUS FORMULATION, SEE PNI A, SAME NSN.
================== Physical/Chemical Properties ==================
HCC:F2
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:172F - 410F
Vapor Density:>1
Spec Gravity:0.888
Evaporation Rate & Reference:<1 (ETHER=1)
Solubility in Water:NIL
Appearance and Odor:THIN CLEAR LIQUID, KETONE-LIKE ODOR
Percent Volatiles by Volume:46.8
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, ALKALIES AND ACIDS
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES, SPARKS, HOT
SURFACES
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE
AND FEDERAL REGULATIONS. INCINERATION RECOMMENDED.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PRO-SEAL 890 B1, B2, B1/2,B4,B8, BASE
Preparer's Name:AO
CAGE:83574
CAGE:83574
CAGE:92108
============= Composition/Information on Ingredients =============
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: <5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:200 PPM; Z-2
ACGIH TLV:S, 50 PPM; 9394
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:PHENOL FORMALDEHYDE RESIN
CAS:9003-35-4
Fraction by Wt: <5%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:CONTACT WITH SKIN & EYES MAY
CAUSE IRRITATION.INHALATION MAY CAUSE IRRITATION TO NOSE &
THROAT;MAY CAUSE ALLERGIC SKIN RASH IN SENSITIZED
INDIVIDUALS.SWALLOWING MAY CAUSE NAUSEA,VOMITING,LIVER & KIDNEY
DAMAGE.CHRONIC:PROLONGED OR REPEATED INHALATION EXPOSURE MAY CAUSE
CNS EFFECTS, LIVER & KIDNEY DAMAGE.
Explanation of Carcinogenicity:NO INGREDIENT OF A CONCENTRATION OF 0.1%
OR GREATER IS LISTED AS A CARCINOGEN OR SUSPECTED CARCINOGEN.
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER. HMIS-INHALED:
HEADACHE, FATIGUE, CONFUSION, DIZZINESS, DROWSINESS, NUMBNESS,
UNCONSCIOUSNESS, SNEEZING, WHEEZING, COUGHING, SHORTNESS OF BREATH.
EYES: REDNESS, SWELLING , BLURRED VISION, TEARING. SKIN-SWELLING,
REDNESS, DISCOMFORT. INGESTED: NAUSEA, VOMITING.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES-FLUSH WITH LUKEWARM WATER FOR 15 MINUTES.IF SYMPTOMS
PERSIST,CONSULT A DOCTOR.SKIN-WASH WITH SOAP AND WATER,CONSULT A
PHYSICIAN.INHALED-REMOVE TO FRESH AIR. IF SYMPTOMS ARE PRESENT
CONSULT A PHYS ICIAN.INGESTED-NONE SPECIFIED BY
MANUFACTURER.HMIS-GET IMMEDIATE MEDICAL ATTENTION. TARGET
ORGANS:LIVER,KIDNEYS,CNS,LUNGS,SKIN.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:153F,67C
Lower Limits:1
Upper Limits:7
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM, WATER.
Fire Fighting Procedures:USE AIR SUPPLIED RESPIRATOR. HMIS- WEAR
SELF-CONTAINED BREATHING APPARATUS AND BUNKER GEAR.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:SCOOP INTO CONTAINERS. CLEAN-UP RESIDUE WITH
1,1,1-TRICHLOROETHANE (HMIS DOES NOT RECOMMEND THIS!).
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER. HMIS-
STORE IN A COOL, DRY PLACE AWAY FROM INCOMPATIBLE MATERIALS.
Other Precautions:THIS PRODUCT CONTAINS A TOXIC CHEMICAL OR CHEMICALS
SUBJECT TO THE REPORTING REQUIREMENTS OF SECTION 313 OF TITLE III
OF THE SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT OF 1986 AND 40
CFR 372.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SPECIFIED BY MANUFACTURER. HMIS- IF
ENGINEERING CONTROLS FAIL OR EMERGENCY OCCURS; USE NIOSH/MSHA
APPROVED RESPIRATOR OR POSITIVE PRESSURE SELF-CONTAINED BREATHING
APPARATUS, AS REQUIRED. USE IAW 29 CFR 1910.134.
Ventilation:USE ADEQUATE MECHANICAL VENTILATION TO MAINTAIN EXPOSURE TO
VAPOR BELOW TLV.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH HANDS AFTER USE AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:V4
Vapor Density:3.2(TOLUEN
Spec Gravity:1.49
Evaporation Rate & Reference:2.6 (TOLUENE)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:OXIDES OF CARBON, SULFUR DIOXIDE,
TRACES OF HYDROGEN SULFIDE, MANGANAESE COMPOUNDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. NOT A HAZARDOUS WASTE ACCORDING TO EPA
REGULATIONS. CONSULT STATE REGULATIONS PRIOR TO DISPOSAL OF
SPILLAGE.
| 1 | gloves_mandatory |
=======================================================
NIIN: 00-299-9807
Product ID: 16484, CARGILL IMMERSION OIL TYPES A & B CODE 1248
Cage: 10684
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 10684
=======================================================
Item Description Information
=======================================================
Item Name: IMMERSION OIL,MICROSCOPY
Specification Number: MIL-I-36698
Type/Grade/Class: TYPES A & B
Unit of Issue: BT
UI Container Qty: 1
Type of Container: 144 BT/CO
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NOT PROVIDED
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: NONE KNOWN AT C.I.U.
Explanation Of Carcinogenicity: NONE
Signs And Symptions Of Overexposure: OILY FEEL, IF LIQUID IS MISTED OR ABOVE
150F (NOT A CONDITIONS OF INTENDED USE) HEADACHES AND NAUSEA POSSIBLE.
Medical Cond Aggravated By Exposure: NO DATA FOUND
First Aid: INHLATION: (NOT LIKELY AT C.I.U.) IF CONCERN ARISES, REMOVE TO FRESH
AIR. SKIN & CLOTHES: PROMPT SOAP AND WATER WASH. EYES: FLUSH WITH WATER,
SLIGHT TEMPORARY IRRITATION POSSIBLE (CONSULT PHYSICIAN). INGESTION: LOW
ORDER OF TOXICITY, FIRST AID NORMALLY NOT NEEDED (CONSULT PHYSICIAN).
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: ABSORB, PLACE IN PLASTIC (POLYETHYLENE OR
POLYPROPLYENE) CONTAINER, CAP OR TWIST TIE CLOSURE.
Neutralizing Agent: NOT PROVIDED
Waste Disposal Methods: ALL CHEMICAL DISPOSAL MUST BE IN ACCORDANCE WITH
CURRENT LOCAL, STATE AND FEDERAL REGULATIONS.
Handling And Storage Precautions: STORE BETWEEN 65F AND 98F (18C AND 32C).
Other Precautions: AVOID CONTINUAL DIRECT SUNLIGHT, VAPORIZING OR ATOMIZING.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: COC
Flash Point: >162.8C, 325.F
Lower Limits: N.D.F.
Upper Limits: N.D.F.
Extinguishing Media: CARBON DIOXIDE, FOAM, DRY CHEMICAL OR ANY CLASS B AGENT
Fire Fighting Procedures: NONE
Unusual Fire/Explosion Hazard: NONE
=======================================================
Control Measures
=======================================================
Respiratory Protection: LOCAL EXHAUST/MECHANICAL GENERAL
Ventilation: LOCAL EXHAUST/MECHANICAL GENERAL
Other Protective Equipment: NOT MANDATORY EXCEPT AS GOOD LABORATORY INDUSTRIAL
PRACTICES.
Work Hygienic Practices: ALWAYS USE GOOD HYGENIC WORK/PRACTICES AS TO
AVOIDANCE OF VAPORS, PROLONGED AND REPEATED SKIN CONTACT.
Supplemental Safety and Health: ABBREVIATION: N/A = NOT APPLICABLE. N/AV = NOT
AVAILABLE. N/K = UNKNOWN. N/P = NOT PROVIDED. N/R = NOT RELEVANT. N/D = NOT
DETERMINED. N/E = NOT ESTABLISHED. CNS = CENTRAL NERVOUS SYSTEM. GI = GASTROI
NTESTINAL. SCBA = SELF CONTAINED BREATHING APPARATUS. N.D.F= NO DATA FOUND.
C.I.U.=CONDITIONS OF INTENDED USE.
=======================================================
Physical/Chemical Properties
=======================================================
HCC: V5
NRC/State LIC No: NOT RELEVANT
Boiling Point: =340.C, 644.F
Melt/Freeze Pt: <0.C, 32.F
Decomp Text: NOT PROVIDED
Vapor Pres: <0.1 @ 73F
Vapor Density: CA 1
Spec Gravity: .9
Viscosity: NOT PROVIDED
Evaporation Rate & Reference: CA 1 (MINERAL OIL=1)
Solubility in Water: NIL
Appearance and Odor: LIGHT YELLOW, SLIGHT CHARACTERISTIC ODOR
Percent Volatiles by Volume: NOT PROVIDED
Corrosion Rate: NOT PROVIDED
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: HEAT ABOVE 150F
Materials To Avoid: STRONG OXIDIZERS
Hazardous Decomposition Products: NOT PROVIDED
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NONE
=======================================================
Toxicological Information
=======================================================
Toxicological Information: NOT PROVIDED
=======================================================
Ecological Information
=======================================================
Ecological: NOT PROVIDED
=======================================================
=======================================================
Transport Information: NOT PROVIDED
=======================================================
Regulatory Information
=======================================================
Sara Title III Information: NOT PROVIDED
Federal Regulatory Information: NOT PROVIDED
State Regulatory Information: NOT PROVIDED
=======================================================
Other Information
=======================================================
Other Information: NONE
=======================================================
Transportation Information
=======================================================
Trans ID NO: 158798
Product ID: 16484, CARGILL IMMERSION OIL TYPES A & B CODE 1248
Review Date: 09/10/2001
Net Unit Weight: 0.0625 LB
Multiple KIT Number: 0
Unit Of Issue: BT
Container QTY: 1
Type Of Container: 144 BT/CO
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: ZZZ
DOT Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: ZZZ
IMO Proper Shipping Name: NOT REGULATED FOR THIS MODE OF TRANSPORTATION
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: ZZZ
IATA Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: ZZZ
AFI Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
HAZCOM Label
=======================================================
Product ID: 16484, CARGILL IMMERSION OIL TYPES A & B CODE 1248
Cage: 10684
Company Name: CARGILLE LABORATORIES INC
Street: 55 COMMERCE ROAD
Zipcode: 07009-1289
Date Of Label Review: 09/10/2001
Status Code: A
Signal Word: NONE
Respiratory Protection IND: NO
Health Hazard: None
Contact Hazard: None
Fire Hazard: None
Reactivity Hazard: None
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ELVAX, 3190LG
Preparer's Name:T E SCHROER
CAGE:18873
CAGE:18873
============= Composition/Information on Ingredients =============
Ingred Name:ETHYLENE-VINYL ACETATE COPOLYMER
> Wt:99.7
Ingred Name:VINYL ACETATE AEL DUPONT: 10 PPM - 8 & 12 HR TWA. WHERE
GOVERNMENTALLY IMPOSED OCCUP EXPOS LIMITS WHICH ARE LOWER THAN AEL
ARE IN EFT, SUCH LIMITS SHALL TAKE PRECEDENCE.
CAS:108-05-4
RTECS #:AK0875000
< Wt:.3
ACGIH TLV:35 MG/M3;10 PPM
ACGIH STEL:53 MG/M3;15 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50: (ORAL,RAT) 2920 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:BEFORE USING "ELVAX" RESINS, READ
BROCHURES ON SAFE HNDLG PROCEDURES. ACUTE: INGEST: THE ORAL LD-50
IN RATS USING 1 TYPE OF "ELVAX" IS IN EXCESS OF 1000 MILLIGRAMS PER
KILOGRAM OF BODY WT. 2 WEEK META BOLIC TESTS WITH DOGS & RATS
SHOWED THAT NO SIGNIFICANT AMOUNT OF POLYMER WAS RETAINED BY
ANIMALS. 90-DAY FEEDING STUDIES IN RATS SHOWED THAT "ELVAX" RESINS
HAVE LOW TOX. SLIGHT LIVER EFTS WERE SEEN I N ANIMALS FED DIETS
CNTNG 10% "ELVAX"; NO EFTS WERE SEEN W/DIETS CNTNG 5% "ELVAX".
OVERALL, NO IMPORTANT BODY SYSTEMS OR ORGAN DYSFUNCTION OCCURRED AT
EITHER DOSE LEVEL. SKIN: NO DATA AVAILABLE. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:VINYL ACETATE. IARC MONOGRAPHS; VOL 63,
PG 443, 1995: GROUP 2B.
Effects of Overexposure:HLTH HAZS: HOWEVER, BASED ON EXPERIENCE W/HNDLG
THESE POLYMERS, NO UNUSUAL DERM HAZ IS EXPECTED FROM ROUTINE HNDLG.
MOLTEN POLYMER CONTACTING SKIN WILL CAUSE THERMAL BURNS. EYE:
MECHANICAL IRRITATION. INHAL: POLYMER IS NOT RESPIRABLE AS
MARKETED. AT PROCESSING TEMPS ABOVE 204 DEGREES C, FUMES IRRITATING
TO EYES, NOSE, AND THROAT MAY BE PRODUCED. EXPOSURE MAY RESULT IN
REDNESS, TEARING, AND ITCHING IN THE EYES TOGETHER WITH SORENESS
IN THE NOSE AND THROAT WITH COUGHING.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. IF NOT BRTHG, GIVE ARTF RESP. IF
BRTHG IS DFCLT, GIVE OXYG. CALL PHYS. SKIN CONT: CMPD IS NOT LIKELY
TO BE HAZ BY SKIN CONT BUT CLEANSING SKIN AFTER USE IS ADVISABLE.
IF MO LTEN MATL GET ON SKIN, COOL RAPIDLY W/COLD WATER. DO NOT
ATTEMPT TO REMOVE MATL FROM SKIN. OBTAIN MEDICAL TREATMENT FOR
THERMAL BURN. EYE CONT: IMMEDIATELY FLUSH W/PLENTY OF WATER FOR AT
LST 15 MINUTE S. CALL PHYSICIAN. INGEST: NO SPECIFIC INTERVENTION
IS INDICATED AS CMPD IS NOT LIKELY TO BE HAZ BY INGEST. CONSULT
PHYSICIAN IF NECESSARY.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:=260.C, 500.F
Extinguishing Media:WATER, FOAM, DRY CHEMICAL, CO*2.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:SOLID POLYMER CAN BE COMBUSTED ONLY
W/DFCLTY. ELECTROSTATIC CHARGE CAN POTNTLY BUILD UP WHEN POURING
PELLETS. GROUNDING OF EQUIP IS REC. HAZ COMBUST PRODS: COMPLETE
COMBUST GIVE CO*2 & WATER. INCOMPLE TE COMBUST GIVES, IN ADDN, CO &
HYDROCARBON OXIDATION PRODS INCL ORGANIC ACIDS, ALDEHYDES, AND
ALCOHOLS.
================== Accidental Release Measures ==================
Spill Release Procedures:SAFEGUARDS (PERSONNEL). NOTE: REVIEW FIRE
FIGHTING MEASURES & HANDLING (PERSONNEL) SECTION BEFORE PROCEEDING
WITH CLEAN-UP. USE APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT DURING
CLEAN-UP. SPILL CLEAN U P: SHOVEL OR SWEEP UP.
======================Handling and Storage ======================
Handling and Storage Precautions:SEE FIRST AID AND PERSONAL PROTECTIVE
EQUIPMENT SECTIONS.
Other Precautions:STORE IN A COOL, DRY PLACE. KEEP CONTAINER CLOSED TO
PREVENT CONTAMINATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:A NIOSH APPRVD AIR PURIFYING RESP W/ORG VAP
CARTRIDGE WITH DUST/MIST FILTER MAY BE PERMISSIBLE UNDER CERTAIN
CIRCUMSTANCES WHERE AIRBORNE CONCS ARE EXPECTED TO EXCEED EXPOS
LIMITS. USE NIOSH APPRVD PO SITIVE PRESS AIR SUPPLIED RESP IF THERE
IS ANY POTNTL FOR UNCONTROLLED RELEASE, EXPOS LEVELS ARE NOT
KNOWN/ANY OTHER CIRCUMSTANCES WHERE NIOSH APPRVD (SUPDAT)
Ventilation:LOC VENT MUST BE USED OVER PROCESSING EQUIP TO MAINTAIN
VINYL ACETATE CONCS IN AIR BELOW PEL. USE STATIC CTLS. STATIC
CHARGES CAN BUILD UP (SUPDAT)
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER . IF
THERE IS POTNTL CONT WITH HOT/MOLTEN MATERIAL, WEAR HEAT RESISTANT
CLOTHING AND FOOTWEAR.
Supplemental Safety and Health
RESP PROT: NIOSH APPRVD AIR PURIFYING RESPS MAY NOT PROVIDE ADEQ PROT.
VENT: AND IGNITE DUST/SOLV LADEN ATM. TOX INFO: RATS BUT NOT IN
MICE. RESEARCH ON MECHANISM OF NASAL TUMOR INDUCTION IN RATS SUGG
ESTS THAT LEVELS @ WHICH HUMANS ARE LIKELY TO BE EXPOS ARE BELOW
THRESHOLD FOR EFTS THAT CONTRIBUTE TO (OTHER INFO)
================== Physical/Chemical Properties ==================
Spec Gravity:0.93-0.97
Solubility in Water:NEGLIGIBLE
Appearance and Odor:TRANSLUCENT TO WHITE PELLETS. MILD ESTER-LIKE ODOR.
Percent Volatiles by Volume:NEGLIGIBLE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
INCOMPATIBLE OR CAN REACT WITH STRONG ACIDS, OXIDIZING AGENTS.
Stability Condition to Avoid:TEMPERATURES ABOVE 230 DEGREES C FOR SHORT
RESIDENCE TIMES. TEMPERATURES ABOVE 204 DEGREES C FOR LONG
RESIDENCE TIMES.
Hazardous Decomposition Products:VINYL ACETATE, ACETIC ACID, CARBON
MONOXIDE AND HYDROCARBON OXIDATION PRODUCTS INCLUDING ORGANIC
ACIDS, ALDEHYDES AND ALCOHOLS.
=================== Toxicological Information===================
Toxicological Information:ANIMAL DATA: VINYL ACETATE. INHAL 4 HR LC50:
4000 PPM IN RATS. SKIN ABSORP LD50: 2335 MG/KG IN RABBITS. ORAL
LD50: 2920 MG/KG IN RATS. VINYL ACETATE IS SLIGHT SKIN & SEV EYE
IRRITANT, & WEAK SKIN SENS ITIZER IN ANIMALS. NO EFTS FROM RPTD
EXPOS TO VINYL ACETATE BY INHAL WERE OBSERVED @ 100 PPM IN RATS.
EXPOS TO HIGHER CONCS OF VINYL ACETATE BY INHAL CAUSED EYE IRRIT &
LACRIMATION, REDUCED WT GAIN, & IRRIT OF RESP TRACT W/BRTHG
DFCLTY. EFTS OBSERVED IN RATS & MICE EXPO BY INHAL TO 200 & 600 PPM
FOR 2 YRS INCL REDUCED BODY WT, & PATHOLOGICAL CHANGES IN NOSE &
RESP TRACT. NASAL CAVITY TUMORS WERE O BSERVED IN (SUPDAT)
===================== Ecological Information =====================
Ecological:AQUATIC TOXICITY: NO INFORMATION IS AVAILABLE. TOXICITY IS
EXPECTED TO BE LOW BASED ON INSOLUBILITY IN WATER.
==================== Disposal Considerations ====================
Waste Disposal Methods:PREFERRED OPTIONS FOR DISP ARE (1) RECYCLING,
(2) INCINERATION W/ENERGY RECOVERY, AND (3) LANDFILL. HIGH FUEL
VALUE OF PROD MAKES OPTION 2 VERY DESIRABLE FOR MATL THAT CANNOT BE
RECYCLED. TREATMENT, S TORAGE, TRANSPORTATION, & DISP MUST BE I/A/W
APPLIC FEDERAL, STATE/PROVINCIAL, & LOCAL REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:SHIPPING INFORMATION. DOT HAZARD CLASS: NOT
REGULATED.
===================== Regulatory Information =====================
SARA Title III Information:VINYL ACETATE: DISCLOSURE AS A TOXIC
CHEMICAL IS REQUIRED UNDER SECTION 313 OF TITLE III OF THE
SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT OF 1986 AND 40 CFR
PART 372.
Federal Regulatory Information:U.S. FEDERAL REGULATIONS. TSCA INVENTORY
STATUS: IN COMPLIANCE WITH TSCA INVENTORY REQUIREMENTS FOR
COMMERCIAL PURPOSES.
State Regulatory Information:STATE RIGHT-TO-KNOW. NO SUBSTANCES ON
STATE HAZ SUBSTANCES LIST, FOR STATES INDICATED BELOW, ARE USED IN
MFR OF PRODS ON THIS MSDS, W/EXCEPTIONS INDICATED. SUBSTANCED ON
PENNSYLVANIA HAZ SUBSTANCES LI ST PRESENT @ CONC OF 1%/MORE (0.01%
FOR SPEC HAZ SUBSTANCE) - NONE KNOWN. WARNING - SUBSTANCES KNOWN TO
STATE OF CALIFORNIA TO CAUSE CANCER, BIRTH DEFECTS/OTHER REPRO HARM
- NONE KNOWN. SUBSTANCES ON NEW JERSEY WORKPLACE HAZ SUBSTANCE
LIST PRESENT @ CONC OF 1%/MORE (0.1% FOR SUBSTANCES IDENTIFIED AS
CARCINS, MUTAGENS/TERATOGENS) - NONE KNOWN.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ZYTEL, FE3491 NC010
Kit Part:Y
Preparer's Name:D.L. LICZWEK
CAGE:B0589
CAGE:82348
CAGE:B0589
============= Composition/Information on Ingredients =============
Ingred Name:NYLON (NYLON 66)
CAS:32131-17-2
Fraction by Wt: >98%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:LUBRICANT
Fraction by Wt: <2%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:STABILIZER
Fraction by Wt: <2%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPDAT:MAY NOT PROVIDE ADEQ PROTECTION.
RTECS #:9999999ZZ
Ingred Name:EYE PROT:SHIELD WHEN POSSIBILITY EXISTS FOR EYE & FACE CONT
DUE TO SPLASHING/SPRAYING OF MOLTEN MATL. NIOSH/MSHA (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5:FULL FACE MASK RESP PROVIDES PROTECTION FROM EYE
IRRITATION.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT)>10,000 MG/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:SINGLE LG ORAL EXPOS (10,000
MG/KG) PRODUCED ONLY SLIGHT INITIAL WEIGHT LOSS. TWO-YEAR TESTS IN
RATS & ONE YEAR TESTS IN DOGS @ LEV OF 10% IN DIET PRODUCED NO
ADVERSE EFTS. RPTD INHAL EXPOS PROD UCED NO GROSS CHANGES & ONLY
MICROSCOPIC LUNG & KIDNEY CHANGES. THE CMPD IS NOT SKIN IRRITANT.
TESTS (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:IN ANIMALS DEMONSTRATE NO CARCIN
ACTIVITY. NO ADVERSE HLTH EFTS ARE EXPECTED FROM HUMAN EXPOS TO
POLYHEXAMETHYLENE ADIPAMIDE, EXCEPT FOR MECH IRRIT OF SKIN & EYES
CAUSE BY PARTICLES. SIGNIFIC ANT SKIN PERMEATION, AND SYSTEMIC TOX,
AFTER CONTACT APPEARS UNLIKELY.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:CONSULT PHYS IF NEC. IF EXPOS TO FUMES FROM
OVERHEATING/COMBUST, MOVE TO FRESH AIR. CONSULT PHYS IF SYMP
PERSIST. SKIN:CLEANSING SKIN AFTER USE IS ADVISABLE. IF MOLTEN
POLYMER GETS ON SKIN, COOLRAPIDLY W/COLD WATER. DO NOT ATTEMPT TO
PEEL POLYMER FROM SKIN. OBTAIN MED TREATMENT FOR THERMAL BURN.
EYE:IMMED FLUSH W/PLENTY OF WATER FOR @ LEAST 15 MINS. CALL PHYS.
INGEST:CONSULT PHYS IF NEC.
===================== Fire Fighting Measures =====================
Flash Point:752F,400C
Extinguishing Media:WATER, FOAM, DRY CHEMICAL, CO*2.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . KEEP PERSONNEL REMOVED AND UPWIND OF FIRE.
Unusual Fire/Explosion Hazard:LG MOLTEN MASSES MAY IGNITE SPONT IN AIR.
WATER QUENCHING OF SUCH MASSES IS GOOD PRACTICE. HAZ GASES/VAP
PRODUCED IN FIRE ARE:AMMONIA, CO; SM AMTS OF (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:NOTE:REVIEW FIRE FIGHT MEASURES & HNDLG (PERS)
SECTIONS BEFORE PROCEEDING W/CLEAN-UP. USE APPROP PERSONAL PROT
EQUIP DURING CLEAN-UP. SWEEP UP TO PVNT A SLIPPING HAZARD.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:COOL, DRY PLACE. KEEP CNTNRS TIGHTLY
CLSD TO PVNT MOISTURE ABSORPTION & CONTAMINATION.
Other Precautions:MEDICAL USE: CAUTION:DO NOT USE IN MED APPLIC
INVOLVING PERM IMPLANTATION IN HUMAN BODY. FOR OTHER MED APPLIC SEE
DU PONT CAUTION BULLETIN NO. H-50102.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPRVD AIR PURIFYING RESP W/ORG VAP
CARTRIDGE & NIOSH/MSHA DUST/MIST FILTER MAY BE PERMISSIBLE UNDER
CERTAIN CIRCUMSTANCES WHERE AIRBORNE CONC ARE EXPECTED TO EXCEED
EXPOS LIM. PROT PROVIDE D BY NIOSH/MSHA AIR PURIFYING (SUPDAT)
Ventilation:LOCAL VENTL TO CONTROL FUMES FROM HOT PROCESSING.
Other Protective Equipment:IF THERE IS POTENTIAL CONT W/HOT MOLTEN
MATL, WEAR HEAT RESIST CLOTHING AND FOOTWEAR.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
% VOLAT:1% (WATER). EXPLO HAZ:HYDROGEN CYANIDE & ALDEHYDES. WASTE DISP
METH:PROVINCIAL, & LOCAL REGS. RESP PROT:RESP IS LIM. USE
NIOSH/MSHA POSITIVE PRESS AIR SUPPLIED RESP IF THERE IS ANY POTNTL
FOR UNCONTROLLED RELEASE, EXPOS LEV ARE NOTKNOWN, OR ANY OTHER
CIRCUMSTANCE WHERE NIOSH/MSHA AIR PURIFYING RESP (ING 4)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>482F,>250C
Spec Gravity:1.22-1.38
Evaporation Rate & Reference:NOT KNOWN
Solubility in Water:INSOLUBLE
Appearance and Odor:GRANULES, NO ODOR
Percent Volatiles by Volume:SUPDAT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS AND OXIDIZING AGENTS.
Stability Condition to Avoid:HEATING ABOVE 340 DEGREES C.
Hazardous Decomposition Products:CYCLOPENTANONE, CARBON MONOXIDE,
ALDEHYDES, AND AMMONIA.
==================== Disposal Considerations ====================
Waste Disposal Methods:PREF OPTIONS FOR DISP ARE (1)RECYCLING, (2)INCIN
W/ENERGY RECOVERY, & (3) LANDFILL. HIGH FUEL VALUE OF PROD MAKES
OPTION 2 VERY DESIRABLE FOR MAT THAT CANNOT BE RECYCLED. TREATMENT
STOR, TRANSPORTATIO N & DISP MUST BE I/A/W APPLIC FED, STATE/
(SUPDAT)
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ZL-15B ZYGLO WATER WASH PENETRANT
Preparer's Name:MR.BRUCE GRAHAM (CHEMIST)
CAGE:37676
CAGE:37676
============= Composition/Information on Ingredients =============
Ingred Name:DISTILLATES,(PETROLEUM)HYDROTREATED MIDDLE
CAS:64742-46-7
RTECS #:JN9379645
Fraction by Wt: <75.0%
Ingred Name:KEROSENE
CAS:8008-20-6
RTECS #:OA5500000
Fraction by Wt: 10.0%
ACGIH TLV:100MG/CUM
Ingred Name:DISTILLATES,(PETROLEUM) HYDROTREATED HEAVY NAPHTHENIC
(NOTED ON EARLIER MSDS EFFECTIVE 01MAY86)
CAS:64742-52-5
RTECS #:PY8035000
Fraction by Wt: <5.0%
===================== Hazards Identification =====================
Health Hazards Acute and Chronic:IRRITATES EYES.
Effects of Overexposure:INHALATION:CAUSES DIZZINESS,DROWSINESS,NAUSEA;
SKIN:LIQUID IRRITATES BY DISSOLVING SKIN OIL; EYES:VAPORS/LIQUID
CAUSES IRRITATION.
Medical Cond Aggravated by Exposure:NOT KNOWN
======================= First Aid Measures =======================
First Aid:INHALATION:REMOVE TO FRESH AIR.IF BREATHING IS DIFFICULT,GIVE
OXYGEN; SKIN:REMOVE CONTAMINATED CLOTHES.WASH OFF WITH FLOWING
WATER.USE SOOTHING LOTION.IF IRRITATION PERSISTS,GET MEDICAL ATTN;
EYES:IMM EDIATELY RINSE/FLUSH WITH COPIOUS AMOUNT OF RUNNING WATER
AND GET MEDICAL ATTENTION; INGESTION:NOT NOTED BY THE
MANUFACTURER.HOWEVER,GET MED ATTN IMMEDIATELY IF INGESTED.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>200F/>93C
Lower Limits:6.0
Upper Limits:1.0
Extinguishing Media:CARBON DIOXIDE,FOAM
Fire Fighting Procedures:KEEP CONTAINERS COOL WITH WATER SPRAY.DO NOT
SPRAY WATER ON BURNING PRODUCT.
Unusual Fire/Explosion Hazard:WHEN INVOLVE IN COMBUSTION,MAY EMIT TOXIC
GASES AT OR ABOVE DECOMPOSITION TEMPERATURE.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE IGNITION SOURCES.SM QTY:WIPE UP OR MOP
UP BUT DO NOT BREATHE VAPORS.PLACE RAGS IN CLOSED DRUMS; LG
QTY:WEAR PERSONAL SAFETY EQUIPMENTS.DIKE AREA FAR AHEAD.ABSORB
LIQUID WITH COMMERCIAL ABSORBEN T.TRANSFER WASTE MATERIAL TO
SALVAGE TANKS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM HEAT SOURCES IN WELL
VENTILATED AREA.AVOID AGAINST PHYSICAL DAMAGE TO CONTAINERS.KEEP
CONTAINERS TIGHTLY CLOSED.
Other Precautions:DO NOT BREATHE VAPORS.DO NOT SMOKE WHILE USING.DO NOT
HEAT ABOVE 130F(54C).AVOID FREQUENT OR PROLONGED SKIN CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR A RESPIRATOR WITH ABSORBENT CARTRIDGE IN
POORLY VENTILATED AREAS.IN CONFINED,UNVENTILATED SPACES,WEAR FULL
MASK WITH AIR SUPPLY.
Ventilation:GENERAL VENTILATION TO KEEP BELOW TLV LIMITS.
Work Hygienic Practices:WASH HANDS WITH SOAP/WATER AFTER HANDLING/USE.
Supplemental Safety and Health
ZL-15B WATER WASH PENETRANT IS ONE PART ITEM; QPL-25135-15 QUALIFIED
ZL-15B UNDER TYPE I,METHOD A,LEVEL 1/2(LEVEL 1 OR 2) OF
MIL-I-25135,REVISION D; NSN ESTABLISHED DURING 1987.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:410F/210C
Vapor Pres:0.5 @ 100F
Vapor Density:>1.0
Spec Gravity:0.88
Solubility in Water:NEGLIGIBLE
Appearance and Odor:GREEN OILY LIQUID,PETROLEUM HYDROCARBON ODOR
Percent Volatiles by Volume:5.0%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HEAT,HIGH TEMPERATURES
Hazardous Decomposition Products:EMITS OXIDES OF CARBON WHEN BURNING.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE OR DISPOSE OF AS EPA HAZARDOUS WASTE
D001 (IGNITABLE WASTE),IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL,STATE,LOCAL REGULATIONS;IF LOCAL REGS PROHIBIT DUMPING
RINSINGS DOWN THE SEWER,PURIFY R INSINGS WITH MAGNAFLUX WASTEWATER
TREATMENT SYSTM.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:EPOCAST 31A A, PRODUCT CODE FPC2055
Kit Part:Y
Preparer's Name:RAJESH S. PATEL
CAGE:0267X
CAGE:0267X
CAGE:02984
============= Composition/Information on Ingredients =============
Ingred Name:VINYL CYCLOHEXENE DIOXIDE
CAS:106-87-6
RTECS #:RN8640000
Fraction by Wt: 25%
Other REC Limits:NONE SPECIFIED
OSHA PEL:S, 10 PPM
ACGIH TLV:S, 10 PPM ;A2; 9192
Ingred Name:PHENOL-FORMALDEHYDE POLYMER, GLYCIDYL ETHER
CAS:28064-14-4
Fraction by Wt: 75%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT) IS UNKNOWN.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE SEVERE EYE IRRITATION ON
DIRECT CONTACT. VAPORS FROM HEAT CURE AND DUST FROM GRINDING,
SANDING, ETC. MAY CAUSE EYE AND RESPIRATORY SYSTEM IRRITATION.
PROLONGED OR REPEATED SKIN CONTACT MAY P RODUCE SKIN IRRITATION.
MAY CAUSE AN ALLERGIC SKIN REACTION. INGESTION MAY CAUSE DIGESTIVE
SYSTEM IRRITATION.
Effects of Overexposure:MAY CAUSE EYE, SKIN & RESPIRATORY TRACT
IRRITATION. MAY CAUSE AN ALLERGIC SKIN REACTION IN CERTAIN
SUSCEPTIBLE INDIVIDUALS. INGESTION MAY CAUSE NAUSEA, VOMITING, AND
DIARRHEA.
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH PRE-EXISTING SKIN
DISORDERS ARE AT A GREATER THAN NORMAL RISK WHEN EXPOSED TO THIS
MATERIAL.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE PERSON TO FRESH AIR. CALL A PHYSICIAN.
EYE: FLUSH IMMEDIATELY WITH LARGE AMOUNTS OF WATER FOR 15 MINUTES.
GET MEDICAL ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING. WASH
WITH SOAP A ND WATER PROMPTLY. INGESTION: DO NOT INDUCE VOMITING.
GET IMMEDIATE MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>225F,>107C
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL, WATER SPRAY.
Fire Fighting Procedures:WEAR BREATHING APPARATUS AND FULL PROTECTIVE
GEAR.
Unusual Fire/Explosion Hazard:DECOMPOSITION OR COMBUSTION MAY PRODUCE
TOXIC PRODUCTS. HEAT CAN CAUSE POLYMERIZATION. HEATED SEALED
CONTAINERS CAN EXPLODE.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. COLLECT SPILLED MATERIALS.
PLACE IN A US DOT APPROVED METAL CONTAINER AND SEAL.
Neutralizing Agent:MIX PART A WITH PART B.
======================Handling and Storage ======================
Handling and Storage Precautions:PREVENT CONTACT WITH EYES AND SKIN.
KEEP CONTAINER CLOSED WHEN NOT IN USE. FOR INDUSTRIAL OR
PROFESSIONAL USE ONLY. FOR IMMEDIATE USE WHEN MIXED.
Other Precautions:THIS PRODUCT CONSISTS OF TWO COMPONENTS. THE
PRECAUTIONS FOR EACH COMPONENT SHOULD BE OBSERVED WHEN SEPARATE OR
MIXED. KEEP OUT OF THE REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED. USE NIOSH/MSHA APPROVED
DUST RESPIRATOR WHEN GRINDING OR SANDING CURED MATERIAL.
Ventilation:PROVIDE SUFFICIENT LOCAL & MECHANICAL(GENERAL) VENTILATION
IN PATTERN/VOLUME TO CONTROL INHALATION EXPOSURES.
Other Protective Equipment:WEAR INDUSTRIAL-TYPE WORK CLOTHING.
Work Hygienic Practices:WASH THOROUGHLY AFTER USE AND BEFORE EATING OR
SMOKING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
THIS IS A TWO PART PRODUCT. EMPTY CONTAINERS MAY RETAIN PRODUCT RESIDUE
OR VAPORS. AIRBORNE PARTICULATE MAY BE GENERATED DURING REMOVAL
OPERATIONS INCLUDING ABRASIVE BLASTING, SANDING OR GRINDING.
================== Physical/Chemical Properties ==================
HCC:T4
Vapor Pres:<0.1
Vapor Density:4.8
Spec Gravity:1.12
Evaporation Rate & Reference:<1 (N-BUTYL ACETATE=1)
Solubility in Water:APPRECIABLE
Appearance and Odor:LIGHT AMBER COLOR LIQUID, SLIGHT ODOR.
Percent Volatiles by Volume:<1
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS, AMINES, AMMONIA, ACIDS, HALOGENS, ANHYDRIDES.
Stability Condition to Avoid:EXTREME TEMPERATURES.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE, AND
DECOMPOSITION PRODUCTS WHEN SUBJECTED TO HIGH HEAT OR FLAME.
Conditions to Avoid Polymerization:HEAT CAN CAUSE POLYMERIZATION.
HEATED SEALED CONTAINERS CAN EXPLODE.
==================== Disposal Considerations ====================
Waste Disposal Methods:MIX PART A WITH PART B. COMPLETELY CURE AND
DISPOSE OF FULLY CURED WASTE PRODUCT IN A SANITARY LANDFILL.
INCINERATE UNCURED BULK PRODUCT AFTER MIXING WITH FLAMMABLE
MATERIAL IN AN INDUSTRIAL FACILITY. DISPOSE OF I/A/W LOCAL, STATE
AND FEDERAL LAWS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:BARIUM IN HNO*3 10,000 UG/ML, I56812
CAGE:0L438
CAGE:0L438
============= Composition/Information on Ingredients =============
Ingred Name:BARIUM (II) NITRATE (1:2)
CAS:10022-31-8
RTECS #:CQ9625000
Fraction by Wt: 0.1-1%
OSHA PEL:0.5 MG/M3 (BA)
ACGIH TLV:0.5 MG/M3 (BA)
Ingred Name:NITRIC ACID
CAS:7697-37-2
RTECS #:QU5775000
Fraction by Wt: 2%
OSHA PEL:2 PPM;4 PPM STEL
ACGIH TLV:2 PPM;4 PPM STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 98%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NONE LISTED BY MANUFACTURER.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:BURNS, COUGHING, IRRITATION, NAUSEA, VOMITING,
LABORED BREATHING.
Medical Cond Aggravated by Exposure:NONE.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR AT LEAST 15 MINUTES. SKIN: FLUSH
WITH WATER FOR 15 MINUTES. WASH CONTAMINATED CLOTHING BEFORE REUSE.
INHAL: REMOVE TO FRESH AIR. INGEST: DO NOT INDUCE VOMITING. GIVE
COPIOUS AMOUNTS OF WATER OR MILK.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:TAKE UP WITH INERT, ABSORBENT MATERIAL.
CONTAINERIZE FOR DISPOSAL. FLUSH SPILL AREA WITH WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A CORROSION FREE AREA. KEEP
CONTAINER SEALED.
Other Precautions:NONE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:LOCAL EXHAUST RECOMMENDED.
Other Protective Equipment:LAB COAT OR APRON.
Work Hygienic Practices:USUAL.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:212F,100C
Spec Gravity:1
Evaporation Rate & Reference:1 (WATER = 1)
Solubility in Water:SOLUBLE
Appearance and Odor:CLEAR, COLORLESS, ODORLESS SOLUTION.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG BASES OR STRONG REDUCING AGENTS.
Stability Condition to Avoid:EXCESSIVE HEAT OR COLD.
Hazardous Decomposition Products:NO*X.
==================== Disposal Considerations ====================
Waste Disposal Methods:CORROSIVE WASTE. DISPOSE OF IN ACCORDANCE WITH
ALL FEDERAL, STATE AND LOCAL ENVIRONMENTAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ALCOHOL
Preparer's Name:LISA WILLIAMS
CAGE:3J969
CAGE:4X459
CAGE:0KZD5
CAGE:3J969
============= Composition/Information on Ingredients =============
Ingred Name:ETHYL ALCOHOL (ETHANOL)
CAS:64-17-5
RTECS #:KQ6300000
Fraction by Wt: 92-100%
Other REC Limits:NONE SPECIFIED
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM; 9192
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 0-7.6%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:HEALTH HAZARDS-ACUTE: EYES, NOSE AND
THROAT IRRITATION. CENTRAL NERVOUS SYSTEM EFFECTS.
Explanation of Carcinogenicity:NONE OF THE INGREDIENTS IN THIS PRODUCT
IS LISTED BY NTP, IARC OR OSHA AS A CARCINOGEN.
Effects of Overexposure:EYES, NOSE, AND THROAT IRRITATION. HEADACHE,
DROWSINESS, LASSITUDE, LOSS OF APETITE, INABILITY TO CONCENTRATE.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES.IF
IRRITATION PERSISTS,SEE DOCTOR. SKIN:WASH WITH MILD SOAP AND WATER
WHILE REMOVING CONTAMINATED CLOTHING AND SHOES. INHALATION:REMOVE
VICTIM T O FRESH AIR.GIVE OXYGEN/CPR IF NEEDED.SEE DOCTOR.
INGESTION:GASTRIC LAVAGE,FOLLOWED BY SALINE CATHARSIS.GET MEDICAL
CARE.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:=12.8C, 55.F
Autoignition Temp:=422.8C, 793.F
Lower Limits:3.28
Upper Limits:19.00
Extinguishing Media:USE CARBON DIOXIDE, ALCOHOL FOAM OR DRY CHEMICAL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED
CONTAINERS WITH WATER SPRAY. CONTAIN RUNOFF.
Unusual Fire/Explosion Hazard:EXPLOSION HAZARD IS MODERATE WHEN EXPOSED
TO FLAME. COMBUSTION OR HEAT OF FIRE MAY PRODUCE HAZARDOUS
DECOMPOSITION PRODUCTS AND VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE PERSONNEL.ELIMINATE IGNITION SOURCES.
VENTILATE AREA.WEAR PROTECTIVE CLOTHING AND EQUIPMENT.DILUTION WITH
WATER WILL DECREASE THE RISK OF A FIRE HAZARD.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY, WELL VENTILATED
AREA. PROTECT FROM PHYSICAL DAMAGE, HEAT, IGNITION SOURCES AND
OXIDIZING AGENTSS. KEEP CONTAINERS CLOSED.
Other Precautions:GROUND CONTAINERS WHEN EMPTYING. AVOID EYE AND SKIN
CONTACT. DO NOT BREATHE VAPORS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED WITH ADEQUATE
VENTILATION. NIOSH/MSHA-APPROVED RESPIRATOR OR SCBA AS APPROPIATE
FOR EXPOSURE OF CONCERN.
Ventilation:MECHANICAL (GENERAL) VENTILATION OR LOCAL EXHAUST
VENTILATION TO KEEP EXPOSURE LEVELS BELOW PEL.
Other Protective Equipment:PROTECTIVE CLOTHING AS REQUIRED TO MINIMIZE
EXPOSURE FROM PROLONGED OR REPEATED CONTACT. EYE BATH AND SAFETY
SHOWER.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING AND BEFORE
EATING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
NONE.
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:=77.8C, 172.F
Vapor Pres:100
Vapor Density:1.59
Spec Gravity:0.789-0.816/60F
Evaporation Rate & Reference:2.7 (BUTYL ACETATE = 1)
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR LIQUID. NEUTRAL ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS SUCH AS ACTYL CHLORIDE, NITRIC ACID, AND HYDROGEN
PEROXIDE.
Stability Condition to Avoid:HEAT AND IGNITION SOURCES.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
INCOMPLETELY BURNED CARBON PRODUCTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTACT YOUR LOCAL ENVIRONMENTAL OFFICER.
DISPOSE OF IN ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL
REGULATIONS. MANUFACTURER STATES SMALL AMOUNTS MAY BE FLUSHED WITH
WATER.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:KENTILE ADHESIVE NO. 1-ASPHALT EMULSION
CAGE:12851
CAGE:12851
============= Composition/Information on Ingredients =============
Ingred Name:ASPHALT (PETROLEUM)
CAS:8052-42-4
RTECS #:CI9900000
Fraction by Wt: 45-55%
Other REC Limits:NONE SPECIFIED
ACGIH TLV:5 MG/M3; (FUME);9192
Ingred Name:CLAY
CAS:1302-78-9
RTECS #:CT9450000
Fraction by Wt: 1-5%
Other REC Limits:NONE SPECIFIED
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 45-55%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: PROLONGED EXPOSURE MAY CAUSE
SLIGHT IRRITATION. EYES: WILL IRRITATE EYES. INGESTION: MAY CAUSE
NAUSEA OR VOMITING.
======================= First Aid Measures =======================
First Aid:SKIN: WASH WITH SOAP AND WATER. EYES: FLUSH W/WATER FOR 15
MINUTES. CONSULT PHYSICIAN IF IRRITATION PERSISTS. INGESTION:
CONTACT A PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:NA
Extinguishing Media:CO2, FOAM, CHEMICALS.
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:CLOSED CANS MAY BURST DUE TO STEAM
PRESSURE.
================== Accidental Release Measures ==================
Spill Release Procedures:DIKE SPILL AREA. RECOVER FREE ADHESIVE INTO
CONTAINER. ADD ABSORBENT TO SPILL AREA.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE AT TEMPERATURES ABOVE 90
F.
Other Precautions:KEEP FROM FREEZING. KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE
Ventilation:NORMAL
Other Protective Equipment:NONE
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:200 TO 220F
Vapor Density:>1
Spec Gravity:1.0
Evaporation Rate & Reference:<1 (BUAC=1); *
Solubility in Water:CAN BE DILUTED
Appearance and Odor:BLACK, MILD ASPHALTIC
Percent Volatiles by Volume:51.0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:NO
NONE
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE AND
LOCAL REGULATIONS.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:5 MINUTE EPOXY GEL RESIN
Kit Part:Y
CAGE:16509
CAGE:0RZG3
CAGE:16509
============= Composition/Information on Ingredients =============
Ingred Name:BISPHENOL A DIGLYCIDYL ETHER RESIN, EPOXY RESIN, EPON 820,
ARALDITE 6004, 4,4'-ISOPROPYLIDENEDIPHENOL-EPICHLOROHYDRIN
CAS:25068-38-6
RTECS #:KD4380000
Fraction by Wt: >60%
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT): 11.4 G/KG EPOXY RESIN
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: MILD-MODERATE IRRITATION. SKIN:
MAY BE ABSORBED THROUGH SKIN, MILD-MODERATE IRRITATION. MODERATE
SKIN SENSITIZER.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION.
Medical Cond Aggravated by Exposure:ALLERGY, ECZEMA, SKIN CONDITION.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR 15 MINS. SKIN: WASH W/SOAP & WARM
WATER. INHALATION: REMOVE TO FRESH AIR. GIVE OXYGEN, IF NEEDED.
INGESTION: DON'T INDUCE VOMITING. GIVE 2 GLASSES OF WATER. OBTAIN
MEDICAL ATTE NTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:400F
Extinguishing Media:CO2, DRY CHEMICAL, FOAM. LARGE: POLYMER FOAM.
Fire Fighting Procedures:WEAR SCBA & PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:PREVENT SKIN & EYE CONTACT. SCRAPE UP &
DISCARD IN SUITABLE CONTAINERS. USE ABSORBENT MATERIAL IF
NECESSARY. WASH AREA W/AN INDUSTRIAL CLEANING AGENT. IF A SOLVENT
IS USED FOR CLEANING, TAKE PRECAUTIO NS AGAINSTFIRE & PERSONAL
OVEREXPOSURE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE. HANDLE
IAW/THE POTENTIAL HAZARD OF THE CURING AGENT USED.
Other Precautions:WEAR ADEQUATE PROTECTIVE EQUIPMENT IF CURED MATERIAL
IS SANDED/MACHINED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED AT NORMAL HANDLING TEMPS.
Ventilation:LOCAL EXHAUST RECOMMENDED FOR CONFINED AREAS. GENERAL IS
ADEQUATE FOR NORMAL USE.
Other Protective Equipment:PROTECTIVE CLOTHING AS REQUIRED
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING & SHOES
BEFORE REUSE. WASH THOROUGHLY AFTER USING & BEFORE EATING/SMOKING.
(SUPP)
Supplemental Safety and Health
WORK HYGIENE CONT'D: DESTROY LEATHER ARTICLES & SHOES THAT CAN'T BE
DECONTAMINATED.
================== Physical/Chemical Properties ==================
Vapor Pres:0
Vapor Density:>1
Spec Gravity:1.2
pH:7
Solubility in Water:INSOLUBLE
Appearance and Odor:BLUE GEL W/FAINT ODOR
Percent Volatiles by Volume:100/WT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS & STRONG ACIDS.
Stability Condition to Avoid:OPEN FLAME & EXCESSIVE HEAT.
Hazardous Decomposition Products:OXIDES OF CARBON, ALDEHYDE & ACIDS.
Conditions to Avoid Polymerization:HEAT IS GENERATED WHEN MIXED W/EPOXY
HARDENER. USE CAUTION WHEN MIXING LARGE QUANTITIES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN WASTE DISPOSAL FACILITY
IAW/FEDERAL, STATE LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:73047-2 STARTING FLUID
CAGE:GO039
CAGE:5L381
CAGE:GO039
============= Composition/Information on Ingredients =============
Ingred Name:ETHANE, 1,1'-OXYBIS-; (ETHYL ETHER) (SARA III)
CAS:60-29-7
RTECS #:KI5775000
Fraction by Wt: >65%
OSHA PEL:400 PPM;500 PPM STEL
ACGIH TLV:400 PPM;500 PPM STEL
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:BUTANE
CAS:106-97-8
RTECS #:EJ4200000
Fraction by Wt: <15%
OSHA PEL:800 PPM
ACGIH TLV:800 PPM
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: <15%
OSHA PEL:1000 PPM
ACGIH TLV:SIMPLE ASPHYXIANT
Ingred Name:CARBON DIOXIDE
CAS:124-38-9
RTECS #:FF6400000
Fraction by Wt: <7%
OSHA PEL:10000 PPM;30000 STEL
ACGIH TLV:5000 PPM;30000 STEL
Ingred Name:N-HEPTANE; (HEPTANE)
CAS:142-82-5
RTECS #:MI7700000
Fraction by Wt: <14%
OSHA PEL:400 PPM;500 PPM STEL
ACGIH TLV:400 PPM;500 PPM STEL
Ingred Name:MINERAL OIL, PETRO DISTILS, SOLV-DEWAXED HEAVY PARAFFINIC
(SEV SOLV-REFINING &/OR HYDROTREATED); (LUBRICATING OIL)
CAS:64742-65-0
RTECS #:PY8038501
Fraction by Wt: <1%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:VOLATILE ORGANIC COMPOUNDS: 100.
RTECS #:9999999VO
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPDAT:SHOULD BE PROVIDED. ISOLATE FROM OXIDIZER CHEMS
CAPABLE OF SPONT HEATING, MATLS REACTING W/AIR OR MOISTURE(ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8:TO LIBERATE HEAT, IGNITION SOURCES & EXPLOSIVES.
CONSULT LOCAL FIRE AUTHORITIES FOR ADDITIONAL STORAGE (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9:INFORMATION. DO NOT PUNCTURE OR INCINERATE
CONTAINERS.
RTECS #:9999999ZZ
Ingred Name:HYGIENE PRACT:DAILY. LAUNDER CLOTHES AT LEAST TWICE WEEKLY.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE:FROSTBITE IS POSSIBLE.
INGEST:FROSTBITE PROBABLE, NECROSIS OF LIP & TONGUE (CONTACTED
TISS). INHAL:PRIMARY RTE OF EXPOSURE. NOTE:HUMAN POISONING
POTENTIAL: SNIFFING FLUOROCARBON PROPELLANTS FOR TH EIR
INTOXICATING EFFECTS IS EXTREMELY DANGEROUS & DEATH MAY OCCUR W/OUT
WARNING. FLUROCCARBONS EXHIBIT (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:VERY TOXIC PROPERTIES, (ASPHYXIATION,
CARDIAC ARRYTHMIAS) WHEN SNIFFED; HOWEVER BECAUSE OF VARIATIONS IN
RESPONSE, IT IS DFCLT TO PREDICT WHICH SYMPS WILL BE EXHIBITED
FOLLOWING EXPOS. BUTANE /PROPANE MAY CAUSE DROW/ASPHY.
SKIN:FROSTBITE IS PROBABLE; BLANCHING OF SKIN, PAIN & TENDERNESS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH W/FRESH WATER FOR AT LEAST 20 MINUTES. CALL MD.
INGEST:KEEP PATIENT CALM, CONSCIOUS & GET TO MD IMMED. GIVE LG QTYS
OF SALT WATER & INDUCE VOMIT. DO NOT MAKE UNCON PERS VOMIT.
INHAL:REMOVE T O FRESH AIR. KEEP WARM & AT REST. IF BRTHG STILL
DFCLT GIVE OXYGEN. IF NOT BRTHG, GIVE ARTF RESP & CHECK FOR PULSE.
IF NO PULSE, START CPR. DO NOT GIVE STIMULANTS (ADRENALINE,
EPINEPHRINE/HAND(SUPDAT)
===================== Fire Fighting Measures =====================
Flash Point:-127F,-88C
Lower Limits:1.9%
Upper Limits:9.5%
Extinguishing Media:WATER FOG, FOAM, CARBON DIOXIDE, DRY CHEMICAL,
HALON.
Fire Fighting Procedures:USE NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP .
KEEP CONTAINERS COOL. USE SHIELDING OR PROT CLTHG TO PROT PERS
AGAINST BURSTING, RUPTURING/VENTING CNTNRS.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:NONE SPECIFIED BY MANUFACTURER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:IGNIT SOURCES SHOULD BE ELIMINATED.
SMOKING SHOULD BE PROHIBITED IN STOR AREAS. DO NOT STORE WHERE
TEMPS COULD EXCEED 54/130F. EXTREMELY FLAMMABLE.
Other Precautions:USE ONLY IN WELL VENTIATED AREAS. DO NOT USE NEAR
OPEN FLAMES/OTHER IGNIT SOURCES, AVOID BRTHG VAPS, SPRAYING IN EYES
& ONTO SKIN. ELEC INSTALLATIONS SHOULD BE I/A/W ARTICLE 501 OF NEC.
NFPA 30 FLAMM & COMBUST CODE, SHOULD BE (SUPP DATA)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:STORE & USE W/ADEQUATE VENTILATION. NEVER USE IN A CLOSED
OR CONFINED SPACE.
Other Protective Equipment:DO NOT WEAR CLOTHING SOAKED BY SPRAY.
Work Hygienic Practices:EXPOS EMPLOYEES SHOULD EXERCISE REAS PERSONAL
CLEANLINESS, WHICH INCLS CLEANING EXPOS SKIN AREAS SEVERAL TIMES
(ING 11)
Supplemental Safety and Health
CNDTNS (STAB):LIGHT ON LONG STANDING. FIRST AID PROC:HELD AEROSOLS.
KEEP PATIENT AT REST FOR 24 HRS AFTER OVEREXP. SKIN:FLUSH EXPOS
AREA W/LUKEWARM WATER/OTHERWISE WARM SKIN SLOWLY. CALL MD. OTHER
PRE C:FOLLOWED FOR ALL STOR & HNDLG. FREQUENT CAREFUL LEAKAGE
INSPECTION SHOULD BE DONE. AUTOMATIC SPRINKLER SYS (ING 8)
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:94.1F,34.5C
Vapor Density:>1.5
Spec Gravity:0.721 (H*2O=1)
Solubility in Water:<0.1%
Appearance and Odor:BLUE LIQUID & BLUE TINGED VAPOR; SLIGHT ETHERAL
ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:EXTREMELY HIGH TEMPS. KEEP AWAY FROM SPKS
& FLAMES. PROD TENDS TO FORM EXPLO PEROXIDES UNDER INFLUENCE OF AIR
& (SUPDAT)
Hazardous Decomposition Products:CO, CO*2.
==================== Disposal Considerations ====================
Waste Disposal Methods:GIVE EMPTY, LEAKING OR FULL CONTAINERS TO
DISPOSAL SERVICE EQUIPPED TO SAFELY HANDLE & DISPOSE OF PRESSURIZED
CONTAINERS. COMPLY W/FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:0.025 N POTASSIUM IODIDE-IODATE SOLUTION
CAGE:0T5H4
CAGE:0T5H4
============= Composition/Information on Ingredients =============
Ingred Name:POTASSIUM IODIDE
CAS:7681-11-0
RTECS #:TT2975000
Fraction by Wt: <1.0%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:IODIC ACID, POTASSIUM SALT; (POTASSIUM IODATE)
CAS:7758-05-6
RTECS #:NN1350000
Fraction by Wt: <1.0%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: NO HARMFUL EFFECTS SHOULD
OCCUR. CHRONIC: NONE SPECIFIED BY MANUFACTURER.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH LARGE AMOUNTS OF WATER FOR AT LEAST 15
MINUTES. INGESTION: DRINK LARGE AMOUNTS OF WATER TO DILUTE STOMACH
CONTENT. IF EFFECTS OCCUR, CONTACT MD. SKIN: FLUSH WITH COPIOUS
AMOUNTS OF WA TER. SEE MD . INHALATION: REMOVE TO FRESH AIR.
SUPPORT BREATHING (GIVE OXYGEN OR ARTIFICIAL RESPIRATION) .
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Extinguishing Media:USE MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:DILUTE WITH WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN OPAQUE CONTAINER AWAY FROM
LIGHT SOURCE. AVOID REPEATED OR PROLONGED CONTACT WITH THIS
SUBSTANCE.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE. USE NIOSH/MSHA APPROVED RESPIRATOR
APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:EMERGENCY EYEWASH & DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA .
Work Hygienic Practices:WASH THOROUGHLY WITH SOAP AND WATER AFTER
HANDLING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
pH:8.2
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, COLORLESS LIQUID, WITH NO ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SANDVIK
CAGE:61005
CAGE:61005
============= Composition/Information on Ingredients =============
Ingred Name:CALCIUM CARBONATE (MARBLE) (LIMESTONE)
CAS:1317-65-3
RTECS #:EV9580000
Fraction by Wt: 1-10%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9192
Ingred Name:CALCIUM FLUORIDE
CAS:7789-75-5
RTECS #:EW1760000
Fraction by Wt: 1-10%
OSHA PEL:2.5 MG(F)/CUM,8H TWA
ACGIH TLV:2.5 MG(F)/CUM
Ingred Name:CHROMIUM (SARA III)
CAS:7440-47-3
RTECS #:GB4200000
Fraction by Wt: 5-30%
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3; 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:COPPER (SARA III)
CAS:7440-50-8
RTECS #:GL5325000
Fraction by Wt: 0-4%
OSHA PEL:0.1MG/M3 FUME/1 DUST
ACGIH TLV:0.2MG/M3 FUME; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:IRON
CAS:7439-89-6
RTECS #:NO4565500
Fraction by Wt: BALANCE
Other REC Limits:NONE ESTABLISHED
Ingred Name:MANGANESE (SARA III)
CAS:7439-96-5
RTECS #:OO9275000
Fraction by Wt: 1-10%
OSHA PEL:(C) 5 MG/M3 DUST
ACGIH TLV:5 MG/M3 DUST 9293
Ingred Name:MOLYBDENUM
CAS:7439-98-7
RTECS #:QA4680000
Fraction by Wt: 1-10%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3; 9293
Ingred Name:NICKEL (SARA III)
CAS:7440-02-0
RTECS #:QR5950000
Fraction by Wt: 1-35%
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3; 9192
Ingred Name:NIOBIUM
CAS:7440-03-1
Fraction by Wt: 1-10%
Other REC Limits:NONE ESTABLISHED
Ingred Name:POTASSIUM, METAL
CAS:7440-09-7
RTECS #:TS6460000
Fraction by Wt: 1-10%
Other REC Limits:NONE ESTABLISHED
Ingred Name:SILICON
CAS:7440-21-3
RTECS #:VW0400000
Fraction by Wt: 1-10%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:SODIUM, METAL
CAS:7440-23-5
RTECS #:VY0688000
Fraction by Wt: 1-10%
Other REC Limits:NONE ESTABLISHED
Ingred Name:CRYOLITE (SODIUM ALUMINUM FLUORIDE; NA*3ALF*6)
CAS:15096-52-3
RTECS #:WA9625000
Fraction by Wt: 1-10%
OSHA PEL:2 MG/CUM(F), TWA
ACGIH TLV:2 MG/CUM(AL), TWA
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 1-20%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:SHORT TERM EXPOSURE TO WELDING FUMES,
GASES OR DUST MAY RESULT IN DISCOMFORT SUCH AS DIZZINESS, NAUSEA,
FEVER, DRYNESS AND/OR IRRITATION OF NOSE, THROAT AND EYES. SKIN
SENSITIVITY MAY ALSO BE NOTED. A CUTE EXPOSURE FROM SOME TOXIC
GASES MAYCAUSE PULMONARY EDEMA, ASPHYXIATION AND EXCESSIVE EXPOSURE
CAN BE FATAL.
Explanation of Carcinogenicity:NICKEL & CHROMIUM COMPOUNDS ARE
CONSIDERED POSSIBLE CARCINOGENS UNDER NTP AND IARC WHEN USED IN
WELDING PROCESS.
Effects of Overexposure:EXPOSURE TO WELDING FUMES MAY RESULT IN
DISCOMFORT SUCH AS DIZZINESS, NAUSEA, FEVER, DRYNESS AND/OR
IRRITATION OF NOSE, THROAT AND EYES. SKIN SENSITIVITY MAY ALSO BE
NOTED. WATERY EYES, HEADACHE, BREA THING DIFFICULTY, FREQUENT
COUGHING AND/OR CHEST PAINS MAY OCCURE FROM ACUTE EXPOSURE. TOXIC
GASES CAN BE FATAL.
Medical Cond Aggravated by Exposure:SOME WORKERS MAY BE AFFECTED BY A
PRE-EXISTING CONDITION OR OTHER OCCUPATIONAL ILLNESS BECAUSE OF THE
WIDE VARIATION IN INDIVIDUAL SUSCEPTIBILITIES.
======================= First Aid Measures =======================
First Aid:REMOVE FROM EXPOSURE AND CALL FOR MEDICAL AID. EMPLOY FIRST
AID T ECHNIQUE RECOMMENDED BY THE AMERICAN RED CROSS.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:USE PROPER MEDIA FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:WELDING ARC AND SPARKS CAN IGNITE
COMBUSTIBLES AND FLAMMABLES.
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN UP ANY GRINDING DUST OR WASTE RESIDUES
AND PLACE IN SUITABLE DOT APPROVED CONTAINERS AND DISPOSE OF IN
FULL COMPLIANCE WITH FEDERAL, STATE AND LOCAL REGULATIONS. AVOID
INHALATION AND SKIN EXPOSU RE.
======================Handling and Storage ======================
CLOTHING WHEN CUTTING, GRINDING OR WELDING. DO NOT EXPOSE SKIN TO
RADIATION WHEN HOT CUTTING OR WELDING.
Other Precautions:NONE STATED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE WELD FUME RESPIRATOR OR AIR SUPPLIED
RESPIRATOR WHEN CUTTING, GRINDING OR WELDING IN A CONFINED SPACE OR
WHERE LOCAL EXHAUST OR GENERAL VENTILATION DOES NOT KEEP EXPOSURE
BELOW RECOMMENDED LIMITS. USE ONLY NIOSH APPROVED RESPIRATORS.
Ventilation:USE ENOUGH VENTILATION WHEN CUTTING, GRINDING OR WELDING TO
KEEP THE DUST, FUMES & GASES FROM THE WORKERS BREATHING ZONE
Other Protective Equipment:FLAME RETARDANT CLOTHING WHEN CUTTING,
GRINDING OR WELDING. DO NOT EXPOSE SKIN TO RADIATION WHEN HOT
CUTTING OR WELDING.
Work Hygienic Practices:WASH THOROUGHLY BEFORE EATING OR SMOKING.
LAUNDER CONTAMINATIED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Appearance and Odor:SOLID WELDING ELETRODE
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE STATED.
Stability Condition to Avoid:NONE STATED.
Hazardous Decomposition Products:WELDING AND CUTTING OPERATION MAY
INCLUDE OXIDES OF THE METALS, CHROMATES, FLUORIDES, COMPLEX
METALLICS, AND OZONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH FEDERAL, STATE &
LOCAL REGULATIONS
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ALCAN ALUMINUM METAL 3XXX SERIES ALLOY, 3004
CAGE:01371
CAGE:01371
============= Composition/Information on Ingredients =============
Ingred Name:ALUMINUM
CAS:7429-90-5
RTECS #:BD0330000
Fraction by Wt: 95-98.9%
OSHA PEL:15MG/M3 DUST;5 RESP
ACGIH TLV:10MG/M3 DUST;5 FUME
Ingred Name:SILICON. % WT: 0.08.1.8
CAS:7440-21-3
RTECS #:VW0400000
Fraction by Wt: SEE ING
OSHA PEL:10 MG/M3 TDUST;5RESP
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:MAGNESIUM. % WT: 0.05-1.3
CAS:7439-95-4
RTECS #:OM2100000
Fraction by Wt: SEE ING
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:MANGANESE. % WT: 0.05-1.8
CAS:7439-96-5
RTECS #:OO9275000
Fraction by Wt: SEE ING
OSHA PEL:5 MG/M3 DUST,C
ACGIH TLV:5 MG/M3 DUST
Ingred Name:CHROMIUM. % WT: 0.05-0.4
CAS:7440-47-3
RTECS #:GB4200000
Fraction by Wt: SEE ING
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:OTHER PREC: "RECOM FOR STOR & HNDLG OF ALUMINUM POWDERS &
PASTE" PUBLISHED BY ALUMINUM ASSOC, 900, NINETEENTH (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6: ST., N.W., WASHINGTON D.C., 20006.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: ALUMINUM & SILICON DUSTS ARE
CONSIDERED NUISANCE PARTICULATES WHICH HAVE LITTLE ADVERSE EFTS ON
LUNGS WHEN EXPOS ARE KEPT UNDER REASONNABLE CTL. SKIN: CAN CAUSE
BURNS. EYE: ALUMINUM DUST CAN IR RITATE EYES (MECH ABRASION).
ALUMINUM FUMES GENERATED DURING WELD/MELT OPERATIONS PRESENT LOW
HLTH (EFTS OF OVEREXP)
Explanation of Carcinogenicity:CHROMIUM:IARC MONOGRAPHS, VOL 49, PG 49,
1990:GRP 1. NTP 6TH ANNUAL REPORT ON CARCINS, 1991: KNOWN TO BE
CARCIN
Effects of Overexposure:HLTH HAZ: RISKS. MIG WELD/PLASMA ARC CUTTING OF
ALUMINUM ALLOYS CAN GENERATE OZONE, NITRIC OXIDES & ULTRAVIOLET
RADIATION. OZONE OVEREXP MAY RSLT IN MUC MEMB IRRIT/PULM
DISCOMFORT. UV RADIA CAN CAUSE SKIN ERYTHEMA & WELDERS FLASH. HIGH
CONC OF FRESHLY FORMED FUMES OF MAGNESIUM OXIDES & MANGANESE OXIDES
& CAN (SUPDAT)
======================= First Aid Measures =======================
First Aid:INHAL: GO TO A VENTILATED AREA. IF DISCOMFORT PERSISTS, GET
MED ATTN. REMOVE TO FRESH AIR. SUPPORT BRTHG (GIVE O2/ARTF RESP) .
SKIN: RINSE WITH PLENTY OF COLD WATER. IF BURN IS SEV, SEEK MED ATT
N. EYE: FLUSH THORO W/WATER FOR @ LST 15 MIN. IF IRRIT PERSISTS,
CONSULT A PHYS. INGEST: CALL MD IMMED .
===================== Fire Fighting Measures =====================
Extinguishing Media:IN CASE OF AN ALUMINUM FIRE, USE A CLASS D DRY
POWDER EXTING/DRY SAND. DO NOT USE WATER/HALOGENATED EXTING MEDIA.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL PROT
EQUIPMENT.
Unusual Fire/Explosion Hazard:NOT A FIRE HAZ UNLESS IN FINELY DIVIDED
FORM. ALUMINUM DUST CAN PRESENT A SEVERE EXPLOSION HAZARD IF
DISPERSED IN AIR.
================== Accidental Release Measures ==================
Spill Release Procedures:RECYCLE. FINELY-DIVIDED ALUMINUM MAY BE
REACTIVE & ITS HAZARD CHARACTERISTIC SHOULD BE DETERMINED PRIOR TO
DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:INGOTS & METAL SCRAP SHOULD BE THORO
DRIED PRIOR TO REMELTING DUE TO EXPLO HAZ. CHECK METAL TEMP W/USUAL
METHS BEFORE HNDLG IT.
Other Precautions:HOT ALUMINUM DOES NOT PRESENT ANY WARNING COLOR
CHANGE; SPECIAL CAUTION SHOULD THEREFORE BE TAKEN IN CASE METAL
WOULD BE HOT. FOR MORE INFO ON HNDLG & STOR OF ALUMINUM, REQUEST A
COPY OF "GUIDELINES F OR HNDLG MOLTEN ALUMINUM" & (ING 6)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR W/DUST
FILTER/ DUST MASK, FOR CONCENTRATIONS ABOVE EXPOSURE LIMITS. MOLTEN
METAL HNDLG REQS USE OF BOTH PRIMARY & SECONDARY PERSONAL PROT
EQUIP. REFER TO "ALUMINUM A SSOCIATION" GUIDELINES.
Ventilation:SPECIAL VENT PROVISIONS MAY BE REQD TO AVOID EXPLO HAZS.
SEE "NATL FIRE PROT ASSOC" CODES, NFPA 65 AND 651.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
MATL TO AVOID: AMMONIUM NITRATE. FINELY DIVIDED ALUMINUM CAN THERMITE
IN PRESENCE OF OXIDES OF COPPER, OF LEAD/OF IRON. EFTS OF OVEREXP:
PRDCE SYMPS OF METAL FUME FEVER. HIGH CONC OF MANGANESE DUST CA N
AFFECT CNS (APATHY, DROW, WEAK & OTHER PROBLEMS RESEMBLING
PARKINSONISM).
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:>900F,>482C
Spec Gravity:2.5-2.9(H*2O=1)
Appearance and Odor:GREY TO SILVER SOLID; ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
FINELY DIVIDED ALUMINUM MAY EXPLODE WHEN MIXED W/HALOGENATED ACIDS,
HALOGENATED SOLVS, BROMATES, IODATES/ (SUPP DATA)
Stability Condition to Avoid:MOLTEN ALUMINUM MAY EXPLODE UPON CONT
W/WATER.
Hazardous Decomposition Products:FINELY DIVIDED ALUMINUM REACTS
W/HALOGENATED ACIDS, WATER AND SODIUM HYDROXIDE TO PRODUCE HYDROGEN
GAS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF WASTE I/A/W FEDERAL, STATE, OR LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:KOVER-STAIN OIL BASE PRIMER, WZ3500
Preparer's Name:L MICHALEWICZ
CAGE:FO649
CAGE:FO649
CAGE:3M602
============= Composition/Information on Ingredients =============
Ingred Name:VM & P NAPHTHA
CAS:64742-89-8
Fraction by Wt: 15%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:BENZIN; (ALIPHATIC HYDROCARBON)
CAS:8030-30-6
RTECS #:DE3030000
Fraction by Wt: 15%
OSHA PEL:100 PPM (MFR)
ACGIH TLV:100 PPM (MFR)
Ingred Name:PALGORSKITE; (SILICATE). LD50:(ORAL,RAT) >9500 MG/KG
CAS:12174-11-7
RTECS #:RT6400000
Fraction by Wt: <5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 10%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:TALC (POWDER), CONTAINING NO ASBESTOS FIBERS; (SILICATE)
CAS:14807-96-6
RTECS #:WW2710000
Fraction by Wt: 15%
OSHA PEL:0.2 FIBERS/CC
ACGIH TLV:0.2 FIBER/CC, A1
Ingred Name:CALCIUM CARBONATE
CAS:471-34-1
RTECS #:FF9335000
Fraction by Wt: 20%
OSHA PEL:15 MG/M3 (MFR)
ACGIH TLV:10 MG/M3 (MFR)
Ingred Name:COATING & MATERIAL VOLATILE ORGANIC COMPOUND:3.66 LBS/IMP
GAL. 3.05 LBS/US GAL. 365 GMS/LTR
RTECS #:9999999VO
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHALATION:HIGH CONCENTRATIONS
OF VAPOR MAY CAUSE HEADACHE, DROWSINESS, DIZZINESS, NAUSEA &
RESPIRATORY IRRIT. SKIN & EYE CONT:LIQUID OR VAPOR MAY CAUSE
IRRITATION. SKIN ABSORP:MAY CAUSE DEFATTI NG ON PROLONGED CONT.
INGESTION:CAN CAUSE DEPRESSION OF CENTRAL NERVOUS SYSTEM, NAUSEA,
VOMITING AND (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:DIARRHEA. CHRONIC:INTENTIONAL MISUSE
BY DELIBERATELY INGESTING, CONCENTRATING/INHALING CONTENTS MAY
CAUSE PERMANENT HARM OR BE FATAL.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN, EYE AND
RESPIRATORY CONDITIONS MAY BE AGGRAVATED BY EXPOSURE TO THIS
PRODUCT.
======================= First Aid Measures =======================
First Aid:INHAL:MOVE PERSON TO FRESH AIR IMMED. IF PERSON HAS STOPPED
BRTHG GIVE ARTF RESP. EYE:FLUSH IMMED W/PLENTY OF COOL WATER FOR @
LST 15 MINS. SKIN:REMOVE ANY CONTAMD CLTHG, WASH BEFORE REUSE. WASH
W/COO L WATER FOR @ LST 15 MINS. INGEST:GIVE PERSON WATER/MILK TO
DILUTE. CALL PHYS/POIS CTL CTR. IF CNDTNS OF EXPOS PERIST/VICTIM IS
UNCON CALL PHYS/SEEK MEDICAL ATTENTION IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:>68F,>20C
Lower Limits:0.7%
Upper Limits:6.0%
Extinguishing Media:FOAM, ALCOHOL FOAM, CO*2, DRY CHEMICAL, WATER FOG,
OTHER.
Fire Fighting Procedures:NONE. USE NIOSH APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:STOP LEAKAGE IF NO RISK IS EVID. ABSORB SM
SPILLS WITH OR APPROP ABSORB MATERIAL. DIKE LG SPILLS. WEAR APPROP
PROT EQUIP & NIOSH APPRVD RESPS. REPORT LG SPILL AS APPLICABLE LAWS
REQUIRE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:FOLLOW NFPA 30 FLAM & COMBUST LIQS
CODE FOR STOR & HNDLG. CONSULT APPLIC LAWS. STORE IN COOL DRY
PLACE. KEEP AWAY FROM OPEN FLAME, HEAT & SPARKS.
Other Precautions:ISOLATE FROM OXIDIZERS. AVOID BRTHG VAP/SPRAY MIST.
USE ONLY W/ADEQ VENT. DO NOT TAKE INTERNALLY. USE ONLY GROUNDED &
EXPLO PROOF EQUIP. EMPTY CNTNRS W/LIQ RESIDUE/VAP IS FLAMM.
SENSITIVITY TO IMPACT: MAY PUNCTURE CNTNR/LOOSEN LID. (SUPDAT)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE APPROP NIOSH APPRVD RESP WHEN VAP/MIST
LEVELS ARE ABOVE ALLOWABLE EXPOS LIMS. MAKE SURE RESP EQUIP IS
PROPERLY FITTED FOR USE, FOLLOWING MFR'S RECOMMENDED HANDLING
PROCEDURES.
Ventilation:USE ONLY EXPLO PROOF EXHAUST EQUIP. EXHAUST ONLY INTO
NON-EXPLO AREAS. MAINTAIN VAP CONCS BELOW ALLOWABLE EXPOS LIMITS.
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER .
PROTECT SKIN WITH APPROPRIATE CLOTHING.
Work Hygienic Practices:WASH HANDS AND EXPOSED AREAS AFTER USE.
Supplemental Safety and Health
OTHER PREC:SENSITIVITY TO STATIC DISCHARGE:DRUM MUST BE GROUNDED &
BONDED WHEN POURING.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>230F,>110C
Vapor Density:LTR/AIR
Spec Gravity:1.1 (H*2O=1)
Evaporation Rate & Reference:SLOWER/N-BUTYL ACETATE
Solubility in Water:NOT SOLUBLE
Appearance and Odor:WHITE, SOLVENT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS. ACIDS.
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME.
Hazardous Decomposition Products:CARBON MONOXIDE ON INCOMPLETE
COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:REFER TO APPLIC LAWS GOVERNING WASTE DISP AND/OR
RECLAMATION OF RECOVERED MATL. PLACE ALL RECOVERED MATL INTO
PROPERLY MARKED CNTNRS FOR DISP AND/OR TRANSPORTATION. DISP MUST BE
I/A/W FEDERAL, STATE & LOCAL REGULATIONS .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:5614/5113/5114 BLACK DRY INK/TONER (REPLENISHER), 6R461
Resp. Party Other MSDS Num.:A-0124; 602E03130
CAGE:TO144
CAGE:TO144
============= Composition/Information on Ingredients =============
Ingred Name:TONER CONTAINING STYRENE/ACRYLATE POLYMER, CARBON BLACK,
POLYPROPYLENE WAX, STYRENE-ETHYLENE/BUTYLENE COPOLYMER.
Minumum % Wt:75.
Maxumum % Wt:90.
Ingred Name:STYRENE-BUTYL ACRYLATE POLYMER; (STYRENE/ACRYLATE POLYMER)
CAS:25767-47-9
Minumum % Wt:80.
Maxumum % Wt:90.
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Minumum % Wt:5.
Maxumum % Wt:10.
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3
Ingred Name:POLYPROPYLENE; (POLYPROPYLENE WAX)
CAS:9003-07-0
RTECS #:UD1842000
Minumum % Wt:5.
Maxumum % Wt:10.
Ingred Name:HYDROGENATED STYRENE-BUTADIENE POLYMER;
(STYRENE-ETHYLENE/BUTYLENE COPOLYMER)
CAS:66070-58-4
Minumum % Wt:1.
Maxumum % Wt:3.
Ingred Name:CARRIER CONTAINING IRON FERRITE CAS# 1309-38-2/1317-61-9.
Minumum % Wt:10.
Maxumum % Wt:25.
Ingred Name:MAGNETITE; (IRON FERRITE)
CAS:1309-38-2
RTECS #:OM4800000
> Wt:99.
Ingred Name:IRON FERRITE
CAS:1317-61-9
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:MINIMAL RESPIRATORY TRACT IRRITATION
MAY OCCUR AS WITH EXPOSURE TO LARGE AMOUNTS OF ANY NON-TOXIC DUST.
Explanation of Carcinogenicity:CARBON BLACK: IARC MONOGRAPHS ON THE
EVALUATION OF CARCINOGENIC RISK OF CHEMICALS TO MAN. VOLUME 65,
PAGE 149, 1996: GROUP 2B.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE WHEN USED AS DESCRIBED BY
PRODUCT LITERATURE.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR AT LEAST 15 MINUTES. SKIN: WASH
WITH SOAP AND WATER. INHALATION: REMOVE FROM EXPOSURE. INGESTION:
DILUTE STOMACH CONTENTS WITH SEVERAL GLASSES OF WATER. ADDITIONAL
INFORMATI ON: NONE.
===================== Fire Fighting Measures =====================
Lower Limits:N.A.
Upper Limits:N.A.
Extinguishing Media:WATER, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . AVOID INHALATION OF SMOKE.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP OR VACUUM SPILLED TONER AND CAREFULLY
TRANSFER INTO SEALABLE WASTE CONTAINER. SWEEP SLOWLY TO MINIMIZE
GENERATION OF DUST DURING CLEAN-UP. IF A VACUUM IS USED, THE MOTOR
MUST BE RATED AS DUST TIGHT. A CONDUCTIVE HOSE BONDED TO THE
MACHINE SHOULD BE USED TO REDUCE STATIC BUILDUP (SEE SECTION 5).
RESIDUE CAN BE REMOVED WITH SOAP AND COLD WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE.
Other Precautions:AVOID PROLONGED INHALATION OF EXCESSIVE DUST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED WHEN USED AS INTENDED IN XEROX
EQUIPMENT. USE NIOSH APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE
OF CONCERN .
INTENDED IN XEROX EQUIP.
Other Protective Equipment:EYEWASH & DELUGE SHOWER MTG ANSI DESIGN
CRITERIA . FOR USE OTHER THAN NORMAL CUSTOMER - OPERATING
RESP MAY BE REQUIRED. (SUPDAT)
Supplemental Safety and Health
OTHER PROT EQUIP: FOR MORE INFO,CNTCT XEROX. TOX INFO:PEL:15 MG/M3
(TOTAL DUST). 5 MG/M3 (RESP DUST).STEL:NE. CEILING: NE. XEROX EXPOS
LIMIT:2.5 MG/M3 (TOTAL DUST) 0.4 MG/M3 (RESP DUST). TOX INFO: ADD N
INFO: RSLTS OBTAINED FROM XEROX SPONSORED, CHRONIC TONER INHAL
STUDY, DEMONSTRATED NO LUNG CHANGE IN RATS(OTHER INFO)
================== Physical/Chemical Properties ==================
Vapor Density:N.A.
Spec Gravity:5 (H*2O=1)
pH:N.A.
Appearance and Odor:BLACK GRANULAR/FAINT ODOR.
Percent Volatiles by Volume:N.A.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Hazardous Decomposition Products:PRODUCTS OF COMBUSTION MAY BE TOXIC.
AVOID BREATHING SMOKE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
=================== Toxicological Information===================
Toxicological Information:THIS MATL HAS BEEN EVALUATED BY XEROX
CORPORATION & INFO BELOW REFLECTS VALUES FOR TONER ONLY. ORAL LD50:
>5 G/KG (RATS) PRACTICALLY NON-TOX. DERMAL LD50: >2G/KG (RABBITS)
PRACTICALLY NON-TOX. INHAL: LC50: >5 MG/L (RATS, 4 HR EXPOS)
PRACTICALLY NON-TOX. >20 MG/L (RATS, CALCULATED 1 HR EXPOS)
NON-POISONOUS DOT. EYE IRRIT: NOT AN IRRIT. SKIN SENSIT: NOT
SENSIT. SKIN IRRIT: NOT AN IRRIT. HUMAN PATCH: NON-SENSITIZING,
NON-IRRITG. MUTAGENICITY: NO MUTAGENICITY DETECTED IN AMES TEST.
CARCIN: NONE PRESENT. AQUATIC LC50: >1125 MG/L (RAINBOW TROUT),
NON-TOX. TLV:10 MG/M3 (TOTAL DUST). 5 MG/M3 (RESPIRAB LE DUST).
(SUP DAT)
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE ONLY IN A CLOSED CONTAINER. THIS
MATERIAL IS NOT A HAZARDOUS WASTE ACCORDING TO FEDERAL REGULATION
40 CFR 261. STATE AND LOCAL WASTE DISPOSAL REQUIREMENTS MAY
HOWEVER, BE MORE RESTRICTIVE. CONSULT WITH THE APPROPRIATE STATE
AND LOCAL AUTHORITIES FOR SPECIFIC INFORMATION.
=================== MSDS Transport Information ===================
Transport Information:DOT PROPER SHIPPING NAME: NOT APPLICABLE (NOT
REGULATED). ID NUMBER: NOT APPLICABLE. HAZARD CLASSIFICATION: NOT
APPLICABLE. PACKING GROUP: NOT APPLICABLE.
===================== Regulatory Information =====================
Federal Regulatory Information:WHMIS STATUS: THIS IS NOT A WHMIS
CONTROLLED PRODUCT.
======================= Other Information =======================
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:FIBERGLASS RESIN,404,694,18-6792
Kit Part:Y
Preparer's Name:M. WHEELOCK
CAGE:16522
CAGE:16522
CAGE:1B236
============= Composition/Information on Ingredients =============
Ingred Name:UNSATURATED POLYESTER RESIN
Fraction by Wt: <65%
Other REC Limits:NONE RECOMMENDED
Ingred Name:STYRENE MONOMER (SARA 313)
CAS:100-42-5
RTECS #:WL3675000
Fraction by Wt: 35%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:S,50PPM/100STEL;9596
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:VOLATILE ORGANIC CONTENT AS LISTED ON MSDS:386 G/L.
RTECS #:9999999VC
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT RELEVANT
ACGIH TLV:NOT RELEVANT
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT) IS UNKNOWN.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYE, SKIN, CNS, LIVER,
KIDNEY, RESPIRATORY & GI TRACTS. ACUTE- MAY CAUSE EYE & SKIN
IRRITATION & DRYNESS OF SKIN. HARMFUL IF INHALED/INGESTED/ABSORBED
THROUGH SKIN. INHALATION MAY CAUSEIRRITATION & CNS EFFECTS. MAY
CAUSE GI PAIN & DISCOMFORT. CHRONIC- MAY CAUSE LIVER, KIDNEY
DAMAGE, DERMATITIS.
Explanation of Carcinogenicity:CONTAINS STYRENE.
Effects of Overexposure:IRRITATION, TEARING, REDNESS AND STINGING OF
EYES, BURNING, DRYING AND CRACKING OF SKIN, NAUSEA, VOMITING,
DIARRHEA, DIZZINESS, HEADACHE, DROWSINESS, WEAKNESS, FATIGUE,
UNCONSCIOUSNESS
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF AILMENTS
OR WITH A PRE-EXISTING DISEASE INVOLVING THE EYES, SKIN, LIVER,
KIDNEY, CNS OR RESPIRATORY TRACT MAY BE AT INCREASED RISK FROM
EXPOSURE.
======================= First Aid Measures =======================
First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALED:MOVE TO FRESH
AIR. PROVIDE CPR/OXYGEN IF NEEDED. EYES:FLUSH WITH WATER FOR 15
MINUTES, HOLDING EYELIDS OPEN. CALL PHYSICIAN. SKIN:WASH WITH SOAP
& WATER. ORAL:DO NOT INDUCE VOMITING (ASPIRATIONHAZARD). GET
MEDICAL ATTENTION IMMEDIATELY. NEVER GIVE ANYTIHING BY MOUTH TO AN
UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:=32.2C, 90.F
Lower Limits:1.1
Upper Limits:6.1
Extinguishing Media:USE DRY CHEMICAL, CARBON DIOXIDE (SMALL FIRE); FOAM
& WATER FOG (LARGE FIRE). COOL FIRE EXPOSED CONTAINERS WITH WATER.
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:FORMS DECOMPOSITION PRODUCTS.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. ELIMINATE SOURCES
OF IGNITION. VENTILATE AREA. PICK UP SPILL WITH NON-FLAMMABLE
ABSORBENT SUCH AS SAND, EARTH, VERMICULITE. GROUND ALL HANDLING
EQUIPMENTS. PREVENT LIQUID FR OM ENTERING SEWERS OR WATERWAYS.
Neutralizing Agent:NOT RELEVANT
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL (BELOW 100F), VENTILATED
AREA, AWAY FROM SOURCES OF IGNITION AND INCOMPATIBLES. BOND &
GROUND CONTAINERS WHEN TRANSFERRING LIQUID.
Other Precautions:AVOID BREATHING VAPORS. DO NOT GET IN EYES, ON SKIN
OR ON CLOTHING. WASH THOROUGHLY AFTER HANDLING. REMOVE CONTAMINATED
CLOTHING. LAUNDER BEFORE REUSE. KEEP OUT OF REACH OF CHILDREN.
AVOID IMPROPER AD DITION OF PROMOTER AND/OR CATALYST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED. IF TLV IS EXCEEDED OR
FOR SYMPTOMS OF OVER EXPOSURE, WEAR NIOSH-APPROVED RESPIRATOR OR
AIR-PURIFYING RESPIRATOR. IN EMERGENCY, WEAR A NIOSH-APPROVED
POSITIVE-PRESSURE SELF-CONT AINED BREATHING APPARATUS.
Ventilation:MECHANICAL (GENERAL AND/OR LOCAL EXHAUST, EXPLOSION-PROOF)
VENTILATION TO MAINTAIN EXPOSURE BELOW TLV(S).
Other Protective Equipment:EYE WASH STATION, SAFETY SHOWER, WORK
CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. WASH THOROUGHLY BEFORE EATING,
DRINKING/SMOKING.
Supplemental Safety and Health
KEY1:F4.
================== Physical/Chemical Properties ==================
HCC:F3
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:=145.C, 293.F
Vapor Pres:5.2
Vapor Density:3.6
Spec Gravity:1.1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR, VISCOUS LIQUID WITH SHARP STYRENATED ODOR
Percent Volatiles by Volume:35
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG ACIDS
Stability Condition to Avoid:HEAT, SPARKS, HOT SURFACES, STATIC
ELECTRICITY, OPEN FLAMES AND OTHER SOURCES OF IGNITION
Hazardous Decomposition Products:IRRITATING, ACRID FUMES
Conditions to Avoid Polymerization:HEAT AND DIRECT SUNLIGHT
==================== Disposal Considerations ====================
Waste Disposal Methods:CONSULT LOCAL AUTHORITIES. DISPOSAL MUST BE MADE
IN ACCORDANCE WITH APPLICABLE FEDERAL, STATE AND LOCAL LAWS AND
REGULATIONS. RECYCLING, REUSING OR INCINERATION IS RECOMMENDED.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TEMPIL PELLETS
Preparer's Name:E. KIMMEL
CAGE:FO450
CAGE:82682
CAGE:FO450
============= Composition/Information on Ingredients =============
Ingred Name:NON-HAZARDOUS FOR INGREDIENTS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NON-HAZARDOUS WHEN USED A DIRECTED.
WHEN HEATED TO 225-1350F VARIOUS DECOMPOSITION PRODUCTS MAY CAUSE:
DIZZINESS, NAUSEA, CNS DEPRESSION, CYANOSIS, GASTROINTESTINAL HARM.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:NON-HA<ARDOUS. IF HEATED TO 225-1350F
DECOMPOSITION PRODUCTS MAY CAUSE: CYANOSIS, ANEMIA, IRRITATION &
SKIN ULCERS. INGESTION: SYPMTOMS OF ANILINE, ANOXEMIA, TOXICITY OF
CNS, DEPRESSION, DIZZINESS, NA USEA, ABDOMINAL PAIN, PARALYSIS,
GASTROINTESTINAL TRACT, KIDNEYS & LIVER DAMAGE.
======================= First Aid Measures =======================
First Aid:SKIN/EYES: FLUSH W/PLENTY OF WATER. OBTAIN MEDICAL ATTENTION.
======================Handling and Storage ======================
Handling and Storage Precautions:OBSERVE GOOD HYGIENIC PRACTICES. AVOID
CONTACT W/EYES, SKIN & CLOTHING. USE W/ADEQUATE VENTILATION.
============= Exposure Controls/Personal Protection =============
Ventilation:LOCAL EXHAUST: ADEQUATE
Work Hygienic Practices:OBSERVE GOOD HYGIENIC PRACTICES.
Supplemental Safety and Health
TEMPIL PELLETS CONTAIN NO LEAD, MERCURY OR CARCINOGENS LISTED IN THE
CODE OF FEDERAL REGULATIONS.
================== Physical/Chemical Properties ==================
Appearance and Odor:PELLETIZED INDUSTRIAL COMPOUNDS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:ACETANILIDE/AROMATIC AMIDE/DI-O-TOLYL
GUANIDINE/PHENOLPHTHALEIN/POTASSIUM & SODIUM CHROMATES/LITHIUM
CPD/BARIUM CHLORIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:STANDARD. OBSERVE ALL FEDERAL, STATE, & LOCAL
LAWS CONCERNING HEALTH & ENVIRONMENT.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:6162
CAGE:99313
CAGE:99313
============= Composition/Information on Ingredients =============
Ingred Name:COBALT (SARA III)
CAS:7440-48-4
RTECS #:GF8750000
OSHA PEL:0.1 MG/M3;AS CO
ACGIH TLV:0.05 MG/M3;DUST 9293
================== Accidental Release Measures ==================
============= Exposure Controls/Personal Protection =============
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:A2
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSAL REQ
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:178 2713,PT B,KODAK EKTACOLOR SM PROCESSING UNIT P1 / RA-2SM
Kit Part:Y
Preparer's Name:NOT PROVIDED
CAGE:19139
CAGE:19139
CAGE:5K871
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Minumum % Wt:80.
Maxumum % Wt:85.
Other REC Limits:NOT PROVIDED
Code:F
Code:F
Ingred
Name:4-(N-ETHYL-N-2-METHANESULFONYLAMINOETHYL)-2-METHYLPHENYLENEDIA
MINE SESQUISULFATE MONOHYDRATE
CAS:25646-71-3
RTECS #:PB0431000
Minumum % Wt:10.
Maxumum % Wt:15.
Other REC Limits:1 MG/M3 (MFR)
OSHA PEL:NOT PROVIDED
ACGIH TLV:NOT PROVIDED
Ingred Name:LITHIUM SULFATE
CAS:10377-48-7
RTECS #:OJ6419000
Minumum % Wt:1.
Maxumum % Wt:5.
Other REC Limits:NOT PROVIDED
OSHA PEL:NOT PROVIDED
ACGIH TLV:NOT PROVIDED
Ingred Name:POTASSIUM SULFITE
CAS:10117-38-1
RTECS #:WT3530000
< Wt:1.
Other REC Limits:NOT PROVIDED
OSHA PEL:NOT PROVIDED
ACGIH TLV:NOT PROVIDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NOT PROVIDED
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: MAY BE HARMFUL IF INHALED.
LIBERATES SULFUR DIOXIDE GAS WHICH CAN CAUSE IRRITATION TO THE
RESPIRATORY TRACT. SOME ASTHMATICS OR HYPERSENSITIVE INDIVIDUALS
MAY EXPERIENCE DIFFICULT BREATHIN G. EYES: CAUSES IRRITATION. MIST
OR VAPOR IRRITATING. SKIN:CAUSES IRRITATION. MAY CAUSE ALLERGIC
SKIN REACTION. INGESTION: HARMFUL IF SWALLOWED. MAY CAUSE
IRRITATION OF THE GASTROINTESTINAL TRACT. S OME ASTHMATICS OR
SULFITE-SENSITIVE INDIVIDUALS MAY EXPERIENCE WHEEZING, CHEST
TIGHTNESS, STOMACH UPSET, HIVES, FAINTNESS, WEAKNESS AND DIARRHEA.
Explanation of Carcinogenicity:AMERICAN CONFERENCE OF GOVERNMENTAL
INDUSTRIAL HYGIENISTS (ACGIH): NONE INTERNATIONAL AGENCY FOR
RESEARCH ON CANCER (IARC): NONE NATIONAL TOXICOLOGY PROGRAM (NTP):
NONE OCCUPATIONAL SAFETY AND HEAL TH ADMINISTRATION (OSHA): NONE
Effects of Overexposure:INHALATION: LIBERATES SULFUR DIOXIDE GAS WHICH
CAN CAUSE IRRITATION TO THE RESPIRATORY TRACT. SOME ASTHMATICS OR
HYPERSENSITIVE INDIVIDUALS MAY EXPERIENCE DIFFICULT BREATHING.
EYES: CAUSES IRRITATION. MIST OR VAPOR IRRITATING. SKIN: CAUSES
IRRITATION. MAY CAUSE ALLERGIC SKIN REACTION. INGESTION: MAY CAUSE
IRRITATION OF THE GASTROINTESTINAL TRACT. SOME ASTHMATICS OR
SULFITE-SENSITIVE INDIVIDUALS M AY EXPERIENCE WHEEZING, CHEST
TIGHTNESS, STOMACH UPSET, HIVES, FAINTNESS, WEAKNESS AND DIARRHEA.
Medical Cond Aggravated by Exposure:SOME ASTHMATICS, HYPERSENSITIVE OR
SULFITE-SENSITIVE INDIVIDUALS MAY EXPERIENCE DIFFICULT BREATHING,
WHEEZING, CHEST TIGHTNESS, STOMACH UPSET, HIVES, FAINTNESS,
WEAKNESS AND DIARRHEA.
======================= First Aid Measures =======================
First Aid:INHALATION: MOVE TO FRESH AIR. TREAT SYMPTOMATICALLY. GET
MEDICAL ATTENTION IF SYMPTOMS PERSIST. EYES: IMMEDIATELY FLUSH WITH
PLENTY OF WATER FOR AT LEAST 15 MINUTES. GET MEDICAL ATTENTION.
SKIN: IMME DIATELY FLUSH WITH PLENTY OF WATER FOR AT LEAST 15
MINUTES WHILE REMOVING CONTAMINATED CLOTHING AND SHOES. GET MEDICAL
ATTENTION. WASH CONTAMINATED CLOTHING BEFORE REUSE. DESTROY OR
THOROUGHLY CLEAN C ONTAMINATED SHOES. INGESTION: INDUCE VOMITING AS
DIRECTED BY MEDICAL PERSONNEL. NEVER GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS PERSON. CALL A PHYSICIAN OR POISON CONTROL CENTER
IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE (CO2), DRY CHEMICAL,
ALCOHOL FOAM
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING. FIRE OR EXCESSIVE HEAT MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:NEUTRALIZE PRIOR TO DISPOSAL. NEUTRALIZATION
AND SEWERING MAY NOT BE ALLOWED IN SOME STATES OR MUNICIPALITIES.
FLUSH TO SEWER WITH LARGE AMOUNTS OF WATER. OTHERWISE, ABSORB
SPILL WITH VERMICULITE OR OTHER INERT MATERIAL, THEN PLACE IN A
CONTAINER FOR CHEMICAL WASTE. CLEAN SURFACE THOROUGHLY TO REMOVE
RESIDUAL CONTAMINATION.
Neutralizing Agent:NOT PROVIDED
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED. KEEP AWAY FROM
INCOMPATIBLE SUBSTANCES. KEEP FROM CONTACT WITH OXIDIZING
MATERIALS.
Other Precautions:AVOID BREATHING MIST OR VAPOR. DO NOT GET IN EYES, ON
SKIN, ON CLOTHING. USE WITH ADEQUATE VENTILATION. WASH THOROUGHLY
AFTER HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF ENGINEERING CONTROLS DO NOT MAINTAIN AIRBORNE
CONCENTRATIONS BELOW RECOMMENDED EXPOSURE LIMITS, AN APPROVED
RESPIRATOR MUST BE WORN.RESPIRATOR TYPE: ACID GAS. IF
RESPIRATORS ARE USED, A PROG RAM SHOULD BE INSTITUTED TO ASSURE
COMPLIANCE WITH OSHA STANDARD 29 CFR 1910.134.
Ventilation:GOOD GENERAL VENTILATION (TYPICALLY 10 AIR CHANGES PER
HOUR) SHOULD BE USED. VENTILATION RATES SHOULD BE MATCHED TO
CONDITIONS.
EXPOSURE.
CLOTHING APPROPRIATE FOR THE RISK OF EXPOSURE. EYE BATH, SAFETY
SHOWER, WASHING FACILITIES
Work Hygienic Practices:NOT PROVIDED
Supplemental Safety and Health
SUPPLEMENTARY LOCAL EXHAUST VENTILATION, CLOSED SYSTEMS, OR RESPIRATORY
PROTECTION MAY BE NEEDED IN SPECIAL CIRCUMSTANCES SUCH AS POORLY
VENTILATED SPACES, EVAPORATION FROM LARGE SURFACES, SPRAY ING,
HEATING, ETC.
================== Physical/Chemical Properties ==================
HCC:B1
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:>100.C, 212.F
Melt/Freeze Pt:M.P/F.P Text:NOT PROVIDED
Decomp Temp:Decomp Text:NOT PROVIDED
Vapor Pres:18 @ 68F
Vapor Density:0.6
Spec Gravity:1.09
pH:1.5
Viscosity:NOT PROVIDED
Evaporation Rate & Reference:NOT PROVIDED
Solubility in Water:COMPLETE
Appearance and Odor:LIGHT TAN LIQUID, SULFUR DIOXIDE ODOR
Percent Volatiles by Volume:80-85 BY WT
Corrosion Rate:NOT PROVIDED
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
BASES, STRONG OXIDIZING AGENTS
Stability Condition to Avoid:NOT PROVIDED
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
OXIDES OF NITROGEN, OXIDES OF SULFUR
=================== Toxicological Information===================
Toxicological Information:MAY CAUSE KIDNEY DAMAGE BASED ON ANIMAL DATA.
LITHIUM SULFATE. THE TOXICOLOGICAL PROPERTIES OF THIS MATERIAL HAVE
NOT BEEN FULLY INVESTIGATED AND ITS HANDLING AND USE MAY PRESENT
ADDITIONAL HAZARDS. T HIS MATERIAL IS PHARMACOLOGICALLY ACTIVE. CAN
CAUSE ADVERSE EFFECTS ON THE FOLLOWING ORGANS/SYSTEMS: NERVOUS
SYSTEM, CARDIOVASCULAR SYSTEM, GASTROINTESTINAL TRACT, ENDOCRINE
SYSTEM, BLOOD. ACUTE TOXIC ITY DATA: FOR
4-(N-ETHYL-N-2-METHANESULFONYLAMINOETHYL)-2-METHYLPHENYLENEDIAMINE
SESQUISULFATE MONOHYDRATE: ORAL LD-50 (MALE RAT):400 MG/KG (TARGET
ORGAN: KIDNEY) ORAL LD-50 (FEMALE RAT): 246 MG/KG DE RMAL LD-50: >
1000 MG/KG
===================== Ecological Information =====================
Ecological:THE FOLLOWING PROPERTIES ARE ESTIMATED FROM THE COMPONENTS
OF THE PREPARATIONS. POTENTIAL TOXICITY: FISH LC50 MG/L: 10-100.
DAPHNID EC50 MG/L: 10-100. ALGAL IC50 MG/L: 10-100. ORGANICS
READILY D EGRADABLE (>70%): YES (7 DAYS). POTENTIAL
BIOACCUMULATION: LOG POW <1. COD (APPROXIMATE G/L): 127. BOD5
(APPROXIMATE G/L): 15. POTENTIAL TOXICITY: WASTE TREATMENT
MICROORGANISMS EC50 (MG/L): >10 0.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT, OR DISPOSAL MAY BE SUBJECT
TO NATIONAL, STATE, OR LOCAL LAWS. NEUTRALIZE PRIOR TO DISPOSAL.
NEUTRALIZATION AND SEWERING MAY NOT BE ALLOWED IN SOME STATES OR
MUNICIPALITIES. FLUSH TO SEWER WITH LARGE AMOUNTS OF WATER. SINCE
EMPTIED CONTAINERS RETAIN PRODUCT RESIDUE, FOLLOW LABEL WARNINGS
EVEN AFTER CONTAINER IS EMPTIED.
=================== MSDS Transport Information ===================
Transport Information:FOR TRANSPORTATION INFORMATION REGARDING THIS
PRODUCT CALL THE KODAK WORLDWIDE TRANSPORTATION HAZMAT HOT LINE:
(716) 722-2400 BETWEEN 8 A.M. AND 5 P.M. (EASTERN STANDARD TIME),
MONDAY THROUGH FRIDAY .
===================== Regulatory Information =====================
SARA Title III Information:CHEMICAL(S) SUBJECT TO THE REPORTING
REQUIREMENTS OF SECTION 313 OR TITLE III OF THE SUPERFUND
AMENDMENTS AND REAUTHORIZATION ACT (SARA) OF 1986 AND 40 CFR PART
372: NONE.
Federal Regulatory Information:NOT PROVIDED
State Regulatory Information:MATERIAL(S) KNOWN TO THE STATE OF
CALIFORNIA TO CAUSE CANCER: NONE MATERIAL(S) KNOWN TO THE STATE OF
CALIFORNIA TO CAUSE ADVERSE REPRODUCTIVE EFFECTS: NONE
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:HYDROGEN PEROXIDE, 30%
CAGE:DO870
CAGE:15747
CAGE:DO870
CAGE:70829
============= Composition/Information on Ingredients =============
Ingred Name:HYDROGEN PEROXIDE (SARA 302)
CAS:7722-84-1
RTECS #:MX0900000
Fraction by Wt: 30%
OSHA PEL:1 PPM
ACGIH TLV:1 PPM; 9495
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 70%
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL RAT) 1518 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE-INHALATION:SEVERE RESPIRATORY
IRRITATION. SKIN:SEVERE IRRITATION OR BURNS. EYE:SEVERE IRRITATION
OR BURNS, PROLONGED CONTACT MAY CAUSE SEVERE EYE DAMAGE, BLINDNESS.
INGESTION: IRRITATION OF ESOP HAGUS & BLEEDING STOMACH ULCERS.
CHRONIC: NONE IDENTIFIED.
Explanation of Carcinogenicity:IARC LISTS MATERIAL AS NOT CLASSIFIABLE
FOR HUMANS W/LIMITED EVIDENCE OF CARCINOGENICITY TO EXPERIMENTAL
ANIMALS.
Effects of Overexposure:INHALED:SEVERE IRRITATION. SKIN:SEVERE
IRRITATION, BURNS. EYE:SEVERE IRRITATION, BURNS.
INGESTION:IRRITATION, STOMACH ULCERS.
Medical Cond Aggravated by Exposure:NONE IDENTIFIED.
======================= First Aid Measures =======================
First Aid:IF IRRITATION PERSISTS OR IS SEVERE, GET MEDICAL ATTENTION.
EYE:FLUSH W/WATER FOR 15 MIN. SKIN:WASH W/SOAP & WATER. REMOVE
CONTAMINATED CLOTHING & LAUNDER BEFORE REUSE. INHALED:REMOVE FROM
EXPOSURE. A ID OR RESTORE BREATHING AS NEEDED. INGESTED:DO NOT
INDUCE VOMITING. GIVE 1-2 GLASSES OF MILK OR WATER TO DRINK. GET
IMMEDIATE MEDICAL ATTENTION. NOTHING BY MOUTH IF UNCONSCIOUS.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:USE WATER SPRAY.
Fire Fighting Procedures:WEAR FULL FACEPIECE POSSITIVE PRESSURE SCBA &
FULL PROTECTIVE CLOTHING. MOVE CONTAINERS FROM FIRE AREA IF W/O
RISK. USE WATER TO COOL FIRE EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:STRONG OXIDIZER. CONTACT WITH COMBUSTIBLE
MATERIALS, FLAMMABLE MATERIALS, OR POWDERED METALS CAN CAUSE FIRE
OR EXPLOSION.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR SCBA & FULL PROTECTIVE CLOTHING. STOP
LEAK IF W/O RISK. KEEP COMBUSTIBLES (WOOD, PAPER, OIL, ETC) AWAY
FROM SPILLED MATERIAL. FLUSH AREA W/FLOODING AMOUNTS OF WATER. (USE
CAUTION).
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE COLOR CODE YELLOW. KEEP
CONTAINER TIGHTLY CLOSED. STORE SEPARATELY & AWAY FROM FLAMMABLE &
COMBUSTIBLE MATERIALS.
Other Precautions:KEEP CONTAINERS OUT OF SUN & AWAY FROM HEAT.
CONTAINERS SHOULD BE COVERED & VENTED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESPIRATORY PROTECTION REQUIRED IF AIRBORNE
CONCENTRATION SUCEEDS TLV. AT CONCENTRATIONS ABOVE 1 PPM, A
SELF-CONTAINED BREATHING APPARATUS IS ADVISED.
Ventilation:USE GENERAL OR LOCAL EXHAUST VENTILATION TO MEET TLV
REQUIREMENTS.
Other Protective Equipment:UNIFORM, PROTECTIVE SUIT RECOMMENDED.
HMIS:EYE WASH & SAFETY SHOWER.
Work Hygienic Practices:WASH HANDS THOROUGHLY WITH SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:D3
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:=107.8C, 226.F
Melt/Freeze Pt:=-25.C, -13.F
Decomp Temp:Decomp Text:NOT GIVEN
Vapor Pres:25
Vapor Density:1.17
Spec Gravity:1.11
pH:3.3
Evaporation Rate & Reference:<1 (BUTYL ACETATE=1)
Solubility in Water:COMPLETE (100%)
Appearance and Odor:CLEAR, COLORLESS LIQUID. SLIGHT ACRID ODOR
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
COMBUSTIBLE & ORGANIC MATERIALS, STRONG REDUCERS, MOST METALS &
METALLIC SALTS, ALKALIES, POROUS MATERIALS.
Stability Condition to Avoid:HEAT.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE I/A/W FEDERAL, STATE & LOCAL
ENVIRONMENTAL REGULATIONS. EPA HAZ WASTE NUMBER: D001, D002
(IGNITABLE, CORROSIVE WASTE).
| 1 | gloves_mandatory |
=======================================================
Product ID: BENZOIN TINCTURE, B407.30
Cage: 0CL96
Resp. Party Other MSDS No.: B407
=======================================================
Contractor Summary
=======================================================
Cage: 0CL96
=======================================================
Item Description Information
=======================================================
=======================================================
Ingredients
=======================================================
Cas: 64-17-5
RTECS #: KQ6300000
% low Wt: 75.
% high Wt: 83.
OSHA PEL: 1900 MG/M3;1000 PPM
ACGIH TLV: 1880 MG/M3;1000 PPM
ACGIH STEL: NOT ESTABLISHED
------------------------------
Cas: 119-53-9
RTECS #: DI1590000
% low Wt: 17.
% high Wt: 25.
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: SEE INGREDIENT 1
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE: SKIN CONTACT: MAY CAUSE SKIN IRRITATION. EYE
CONTACT: MAY IRRITATE OR BURN THE EYES. INGESTION: HARMFUL IF SWALLOWED.
INGESTION MAY CAUSE NAUSEA, VOMITING AND GASTROINTESTINAL IRRITATION AND BU
RNS TO THE MOUTH AND THROAT. INHALATION: IRRITATION OF NOSE AND THROAT.
HEADACHE, NAUSEA, VOMITING, DIZZINESS, DROWSINESS, UNCONSCIOUSNESS. CHRONIC:
NONE IDENTIFIED. TARGET ORGANS: NONE IDENTIFIED. RE PRODUCTIVE EFFECTS: ETHYL
ALCOHOL HAS BEEN LINKED TO BIRTH DEFECTS IN HUMANS.
Explanation Of Carcinogenicity: NONE IDENTIFIED.
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: NONE IDENTIFIED.
First Aid: SKIN CONTACT: WASH WITH SOAP AND WATER. SEEK MEDICAL ATTENTION IF
IRRITATION DEVELOPS. EYE CONTACT: FLUSH WITH WATER FOR AT LEAST 15 MINUTES.
SEEK IMMEDIATE MEDICAL ATTENTION. INHALATION: REMOVE TO FR ESH AIR.
INGESTION: GIVE VICTIM LARGE AMOUNTS OF WATER AND INDUCE VOMITING. NEVER GIVE
ANYTHING BY MOUTH TO AN UNCONSCIOUS OR CONVULSING PERSON. SEEK IMMEDIATE
MEDICAL ATTENTION. ADDITIONAL FIRST AID TREATMENT NOTES: NO INFORMATION
AVAILABLE.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: REMOVE ALL POTENTIAL IGNITION SOURCES! WEAR FULL
PROTECTIVE EQUIPMENT INCLUDING SUITABLE RESPIRATORY PROTECTION. CONTAIN SPILL
AND TAKE UP WITH INERT MATEIRAL. PLACE INTO SUITABLE CONTAINER FOR DISPOS AL.
Waste Disposal Methods: DISPOSE IN ACCORDANCE WITH ALL LOCAL, STATE AND FEDERAL
REGULATIONS.
Handling And Storage Precautions: STORAGE AREA: FLAMMABLE LIQUID. STORE IN A
COOL, DRY, WELL-VENTILATED FLAMMABLE LIQUIDS STORAGE AREA OR CABINET. PROTECT
CONTAINERS FROM PHYSICAL DAMAGE. BOND AND GROUND CONTAINERS WHEN TRANSFERRING
L IQUID.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: NA
Autoignition Temp Text: NA
Lower Limits: NA
Upper Limits: NA
Extinguishing Media: CO*2, DRY CHEMICAL OR ALCOHOL FOAM. WATER MAY BE
INEFFECTIVE.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N). USE WATER TO COOL NEARBY CONTAINERS AND STRUCTURES.
Unusual Fire/Explosion Hazard: VAPORS MAY FLOW ALONG SURFACES TO DISTANT
IGNITION SOURCES AND FLASH BACK.
=======================================================
Control Measures
=======================================================
Respiratory Protection: IF VENTILATION CONTROLS DO NOT LIMIT AIRBORNE
CONCENTRATIONS BELOW PEL OR TLV VALUES, A NIOSH APPROVED RESPIRATOR MUST BE
WORN. USE A NIOSH APPROVED CHEMICAL CARTRIDGE RESPIRATOR WITH AN ORGANIC
VAPOR CARTRIDGE.
Ventilation: USE GENERAL OR LOCAL EXHAUST VENTILATION TO MEET TLV AND PEL
REQUIREMENTS.
Other Protective Equipment: ANSI APPROVED EYE WASH AND DELUGE SHOWER (FP N).
Work Hygienic Practices: USE GOOD CHEMICAL HANDLING PRACTICES.
=======================================================
Physical/Chemical Properties
=======================================================
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: HEAT, SPARKS AND OPEN FLAME.
Materials To Avoid: INCOMPATIBLE WITH STRONG OXIDIZERS.
Hazardous Decomposition Products: OXIDES OF CARBON (CO, CO*2).
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: WILL NOT OCCUR.
=======================================================
Toxicological Information
=======================================================
Toxicological Information: ETHYL ALCOHOL: LC50 (INHALATION, RAT): 20000
PPM/10H. LD50 (INTRAVENOUS, RAT): 1440 MG/KG. LDLO (SKIN , RABBIT): 20 G/KG.
BENZOIN GUM: NO INFORMATION AVAILABLE.
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
Transport Information: REGULATED MATL DOMESTIC GROUND TRANSPORTATION
(REFERENCE: CFR TITLE 49, TRANSPORTATION). PROPER SHIPPING NAME: TINCTURES,
MEDICINAL. UN/NA IDENTIFICATION NUMBER: UN1293. PACKING GROUP: II. HAZ CLASS
& LABEL: 3. FLAMMABLE LIQUID. REGULATED MATL VIA AIR TRANSPORTATION
(REFERENCE: ICAO TECHNICAL INSTRUCTIONS FOR SAFE TRANSPORT OF DANGEROUS GOODS
BY AIR). PROPER SHIPPING NAME: TINCTURES, MEDICINAL. UN IDENTIFICATION
NUMBER: UN1293. PACKING GROUP: II. HAZ CLASS & LABEL: 3. FLAMMABLE
LIQUID. PACKING INSTRUCTION: PASSENGER AIRCRAFT: 305/Y305, CARCO AIRCRAFT:
307. MAX NET QTY PER PACKAGE: PASSENGER AI RCRAFT: 5/1 L, CARCO AIRCRAFT: 60
L
=======================================================
Regulatory Information
=======================================================
Sara Title III Information: SARA HAZARD CATEGORIES: ETHYL ALCOHOL: ACUTE,
CHRONIC, FLAMMABLE.
Federal Regulatory Information: TSCA INVENTORY: ETHYL ALCOHOL AND BENZOIN GUM.
=======================================================
Other Information
=======================================================
Other Information: RATING: 1-3-0-C. NFPA RATING: NOT ESTABLISHED. WARNING
LABEL: DANGER! FLAMMABLE LIQUID. KEEP AWAY FROM HEAT, SPARKS AND OPEN FLAME.
MAY BE HARMFUL IF SWALLOWED. AVOID CONTACT WITH SKIN, EYES AND CLOTHING.
=======================================================
HAZCOM Label
=======================================================
Product ID: BENZOIN TINCTURE, B407.30
Cage: 0CL96
Company Name: INTEGRA CHEMICAL COMPANY
Street: 710 THOMAS AVE SW
Zipcode: 98055
Label Required IND: Y
Date Of Label Review: 12/30/1999
Status Code: A
Origination Code: F
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: Severe
Reactivity Hazard: None
Hazard And Precautions: FLAMMABLE LIQUID. KEEP AWAY FROM HEAT, SPARKS AND OPEN
FLAME. ACUTE: SKIN CONTACT: MAY CAUSE SKIN IRRITATION. EYE CONTACT: MAY
IRRITATE OR BURN THE EYES. INGESTION: HARMFUL IF SWALLOWED. INGESTION MAY
CAUSE NAUSEA, VOMITING AND GASTROINTESTINAL IRRITATION AND BURNS TO THE MOUTH
AND THROAT. INHALATION: IRRITATION OF NOSE AND THROAT. HEADACHE, NAUSEA,
VOMITING, DIZZINESS, DROWSINESS, UNCONSCIOUSNESS . CHRONIC: NONE IDENTIFIED.
TARGET ORGANS: NONE IDENTIFIED. REPRODUCTIVE EFFECTS: ETHYL ALCOHOL HAS BEEN
LINKED TO BIRTH DEFECTS IN HUMANS.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MAGNOLIA 1066-6
CAGE:22121
CAGE:22121
============= Composition/Information on Ingredients =============
Ingred Name:EPOXY RESIN
Fraction by Wt: 50-60%
Ingred Name:VINYLCYCLOHEXENE DIEPOXIDE (SUSP HUMAN CARC BY ACGIH, SUSP
ANIMAL CARC BY IARC - GROUP 2B; SUSP CARC BY NTP) *95-4*
CAS:106-87-6
RTECS #:RN8640000
Fraction by Wt: 5-15%
ACGIH TLV:10 PPM (SKIN) (A2)
Ingred Name:ALUMINUM (POWDER) *95-4*
CAS:7429-90-5
RTECS #:BD0330000
Fraction by Wt: 5-15%
OSHA PEL:15 MG/CUM
ACGIH TLV:10 MG/CUM (DUST)
Ingred Name:SILICA, AMORPHOUS FUMED (IARC CARCINOGEN - GROUP 3) *95-4*
CAS:112945-52-5
RTECS #:VV7310000
Fraction by Wt: 1-3%
OSHA PEL:0.1 MG/CUM
ACGIH TLV:0.1 MG/CUM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:SKIN: MODERATE IRRITATION, SENSITIZER.
EYES: MODERATE IRRITATION. INGESTION: LOW ORDER OF TOXICITY.
Explanation of Carcinogenicity:SEE INGREDIENTS. ACCORDING TO MAGNOLIA
PLASTICS VINYL CYCLOHEXNE DIEPOXIDE IS AN OSHA CARCINOGEN.
Effects of Overexposure:IRRITATION
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN & EYE DISORDERS.
======================= First Aid Measures =======================
First Aid:SKIN: WASH W/SOAP & WATER. EYES: FLUSH W/WATER FOR 15 MINS.
INHALATION: REMOVE TO FRESH AIR. GIVE CPR IF NEEDED. INGESTION:
DON'T INDUCE VOMITING. GIVE LARGE DOSES OF WATER. OBTAIN MEDICAL
ATTENTION I N ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>200F
Extinguishing Media:WATER SPRAY, FOAM, DRY CHEMICAL, CO2
Fire Fighting Procedures:AVOID BREATHING SMOKE. CONFINED AREAS: USE
FULL EQUIPMENT W/NIOSH APPROVED SCBA. COOL EXPOSED CONTAINERS
W/WATER.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:AVOID CONTACT W/LIQUIDS & VAPORS. WIPE
W/CLOTH/COLLECT ON ABSORBENT MATERIAL. LARGE: DIKE & CONTAIN.
PUMP/SHOVEL INTO SALVAGE VESSELS.
======================Handling and Storage ======================
Handling and Storage Precautions:FOR INDUSTRIAL USE ONLY. STORE IN
COOL, DRY AREA IN TIGHTLY CLOSED CONTAINERS. USE W/ADEQUATE
VENTILATION.
Other Precautions:AVOID CONTACT W/SKIN & EYES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOR EXCESSIVE VAPORS/TO MAINTAIN TLV, A NIOSH
APPROVED RESPIRATOR FOR ORGANIC VAPORS.
Ventilation:LOCAL EXHAUST/MECHANICAL VENTILATION.
Other Protective Equipment:IMPERVIOUS CLOTHING & BOOTS, EYE-WASH
STATION, SAFETY SHOWER.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. USE GOOD HYGIENE PROCEDURES.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>225F
Vapor Pres:0
Vapor Density:>1
Spec Gravity:1.35
Evaporation Rate & Reference:(BU AC =1): <1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:GRAY VISCOUS LIQUID
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG LEWIS ACIDS, STRONG MINERAL ACIDS.
Stability Condition to Avoid:ELEVATED TEMPERATURES
Hazardous Decomposition Products:CO, ALDEHYDES, ACIDS
Conditions to Avoid Polymerization:REACTION W/SOME CURING AGENTS IN
BULK IS EXOTHERMIC.
==================== Disposal Considerations ====================
Waste Disposal Methods:CURE, THEN BURY/INCINERATE. REMOVE SALVAGE
VESSELS TO WASTE DISPOSAL SITE OPERATING IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PSI 621 LOW MODULUS SILICONE SEALANT
Preparer's Name:E. F. CLUFF
CAGE:0KND3
CAGE:0KND3
============= Composition/Information on Ingredients =============
Ingred Name:SILICONE CROSSLINKERS
Fraction by Wt: 8%
OSHA PEL:100 PPM
Ingred Name:CALCIUM CARBONATE
CAS:1317-65-3
RTECS #:EV9580000
Other REC Limits:NONE SPECIFIED
Ingred Name:DIISODECYL PHTHALATE
CAS:26761-40-0
RTECS #:TI1270000
Other REC Limits:NONE SPECIFIED
Ingred Name:POLYEURETHANE RESIN
Other REC Limits:NONE SPECIFIED
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Other REC Limits:NONE SPECIFIED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:VOC: 0.4 LBS/GAL
RTECS #:9999999VO
Other REC Limits:NONE SPECIFIED
Ingred Name:VOC: 48 GRAMS/LITER
RTECS #:9999999VO
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:INHALATION: IRRITATION OF MUCOUS
MEMBRANES. INGESTION: IRRITATION OF INTESTINAL TRACT. SKIN CONTACT:
IRRITATION. EYE CONTACT: IRRITATION.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. INGESTION: DO NOT INDUCE
VOMITING, CONSULT A PHYSICIAN. SKIN CONTACT: WASH WITH SOAP AND
WATER. EYE CONTACT: FLUSH WITH WATER AT LEAST 15 MINUTES. CONSULT A
PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:>200F,>93C
Extinguishing Media:DRY CHEMICALS, FOAM, WATER, CO2. *NEUTRAL
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:TOXIC GASES AND AEROSOLS MAY BE PRODUCED
BY COMBUSTION.
================== Accidental Release Measures ==================
Spill Release Procedures:USE AN ABSORBENT OR LET CURE IN AIR.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE BELOW 122 F (50 C).
Other Precautions:DO NOT INGEST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:ORGANIC VAPOR CARTRIDGE RESPIRATOR IN
UNVENTILATED AREAS.
Ventilation:GENERAL MECHANICAL RECOMMENDED; LOCAL EXHAUST MAY BE
REQUIRED IN POORLY VENTILATED, CLOSED QUARTERS.
Other Protective Equipment:RUBBER APRON.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Vapor Pres:<10 MM HG
Vapor Density:>1
Spec Gravity:1.4
pH:*
Evaporation Rate & Reference:>1
Solubility in Water:0
Appearance and Odor:PASTE; AROMATIC ODOR.
Percent Volatiles by Volume:14
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID EXPOSURE TO MOISTURE DURING STORAGE.
Stability Condition to Avoid:STORE BELOW 50 C.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN LANDFILL AS SYNTHETIC RUBBER SCRAP.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ZINC CARBONATE, 4312
CAGE:4W981
CAGE:4W981
CAGE:70829
============= Composition/Information on Ingredients =============
Ingred Name:CARBONIC ACID, ZINC SALT (1:1); (ZINC CARBONATE) (SARA III)
CAS:3486-35-9
RTECS #:FG3375000
Fraction by Wt: 90-100%
OSHA PEL:10 MG/M3;ZNO
ACGIH TLV:10 MG/M3;ZNO
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL/SKIN/EYE/SKIN
ABSORPTION/INGEST:NONE IDENTIFIED. CHRONIC:NONE IDENTIFIED.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE IDENTIFIED.
======================= First Aid Measures =======================
First Aid:INGEST:IF SWALLOWED & THE PERSON IS CONSCIOUS, IMMED GIVE
LARGE AMOUNTS OF WATER. GET MED ATTN. INHAL:IF PERSON BREATHES IN
LARGE AMOUNTS, MOVE EXPOSED PERSON TO FRESH AIR. SKIN:IMMED WASH
WITH PLENTY OF SOAP AND WATER FOR AT LEAST 15 MINUTES. EYE:IMMED
FLUSH WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT WITH FULL FACEPIECE OPERATED IN POSITIVE PRESSURE MODE.
Unusual Fire/Explosion Hazard:NONE IDENTIFIED.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR SUITABLE PROTECTIVE CLOTHING. CAREFULLY
SWEEP UP AND REMOVE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED.
SUITABLE FOR ANY GENERAL CHEMICAL STORAGE AREA.
Other Precautions:NONE SPECIFIED BY MANUFACTURER. AVOID CONTACT WITH
EYES, SKIN AND CLOTHING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED WHERE ADEQUATE VENTILATION
CONDITIONS EXIST. IF AIRBORNE CONCENTRATION IS HIGH, USE NIOSH/MSHA
APPROPRIATE RESPIRATOR OR DUST MASK.
Ventilation:USE ADEQUATE GENERAL OR LOCAL EXHAUST VENTILATION TO KEEP
FUME OR DUST LEVELS AS LOW AS POSSIBLE.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:4.40 (H*20=1)
Solubility in Water:NEGLIGIBLE (<0.1%)
Appearance and Odor:WHITE POWDER
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS.
Stability Condition to Avoid:NONE DOCUMENTED.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE, AND LOCAL ENVIRONMENTAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:GLY OXIDE LIQUID
CAGE:NO371
CAGE:24268
CAGE:NO371
============= Composition/Information on Ingredients =============
Ingred Name:GLYCERIN
CAS:56-81-5
RTECS #:MA8050000
Fraction by Wt: 86%
Other REC Limits:NONE SPECIFIED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 (MIST) 9293
Ingred Name:HYDROGEN PEROXIDE (SARA III)
CAS:7722-84-1
RTECS #:MX0900000
Fraction by Wt: 3%
Other REC Limits:NONE SPECIFIED
OSHA PEL:1 PPM
ACGIH TLV:1 PPM; 9192
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (INH RAT) IS 2600 MG/KG
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: IRRITATING TO THE BODY TISSUES,
MAY BLEACH THE SKIN. NO CHRONIC HAZARD GIVEN.
Explanation of Carcinogenicity:THIS PRODUCT IS NOT LISTED BY IARC, NTP,
OR OSHA AS A CARCINOGEN.
Effects of Overexposure:EYE:IRRITATION. SKIN:POSSIBLE MILD IRRITATION,
BLEACHING.INHALED:HIGHLY UNLIKELY EXPOSURE. INGESTED:POSSIBLE
MILD DIARRHEA (LAXATIVE EFFECT0 FROM THE GLYDCERIN.
Medical Cond Aggravated by Exposure:NONE
======================= First Aid Measures =======================
First Aid:EYE:FLUSH W/WATER 15 MIN, HOLD LIDS OPEN. SKIN:REMOVE
CONTAMINATED CLOTHING AND LAUNDER BEFORE REUSE. WASH WITH SOAP &
WATER. INHALED:UNLIKELY EXPOSURE. INGESTED:IF OOVER 60ML INGESTED;
GIVE 2 LARGE G LASSES OF MILK OR WATER. (NOTHING BY MOUTH IF
UNCONSCIOUS.) GET IMMEDIATE MEDICAL CARE. IF ANY IRRITATION
PERSISTS OR IS SEVERE, SEE A DOCTOR.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Extinguishing Media:PRODUCT IS NON COMBUSTABLE. EXTINGUISH FIRE WITH
MEDIA APPROPRIATE FOR SOURCE OF FIRE.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. EVACUATE AREA. COOL
FIRE EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:HYDROGEN PEROXIDE WILL REACT WITH
COMBUSTABLE MATERIAL. THE HEAT THUS GENERATED MAY CAUSE IGNITION.
================== Accidental Release Measures ==================
Spill Release Procedures:DILUTE WITH LARGE AMOUNTS OF WATER.
Neutralizing Agent:NOT APPLICABLE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AT ROOM TEMPERATURE IN A DRY,
WELL VENTILATED AREA. KEEP CONTAINERS TIGHTLY CLOSED WHEN NOT IN
USE.
Other Precautions:AVOID CONTACT WITH EYES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NORMALLY REQUIRED.
Ventilation:NORMAL VENTILATION IS USUALLY SUFFICIENT.
Other Protective Equipment:NONE
Work Hygienic Practices:USE GOOD CHEMICAL HYGIENE PRACTICE. AVOID
PROLONGED/REPEATED CONTACT.
Supplemental Safety and Health
THIS PRODUCT IS INTENDED FOR USE AS CLEANSING ANTISEPTIC FOR USE IN THE
MOUTH. HEALTH CARE PROFESSIONALS WHO MAY COME IN CONTACT
REPEATEDLY OR FOR PROLONGED TIMES SHOULD WEAR SURGICAL RUBBER
================== Physical/Chemical Properties ==================
HCC:N1
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR VISCOUS LIQUID, SLIGHT ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
COMBUSTABLE MATERIALS
Stability Condition to Avoid:NONE GIVEN BY MANUFACTURER (SUPPLIER).
Hazardous Decomposition Products:OXYGEN (PROMOTES BURNING)
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE I/A/W FEDERAL,STATE,LOCAL REGULATIONS.
MFR SUGGESTS FLUSH TO SEWER IF PERMITTED.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:TPC-1 TONER
CAGE:MATSU
CAGE:61058
CAGE:MATSU
============= Composition/Information on Ingredients =============
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: 4.5%
OSHA PEL:3.5MG/M3
ACGIH TLV:3.5MG/M3
Ingred Name:METHYL METHACRYLATE-BUTYL ACRYLATE-STYRENE COPOLYMER;
(STYRENE ACRYLATE COPOLYMER)
CAS:27136-15-8
Fraction by Wt: 90.5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:POLYPROPYLENE. (MFR CAS 25085-53-4)
Fraction by Wt: 3.5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:DYE; (ORGANIC PIGMENT:CONTAINS ING 4,5,6)
CAS:84179-66-8
Fraction by Wt: <1.5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:DYE; (ORGANIC PIGMENT)
CAS:109125-50-0
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:DYE; (ORGANIC PIGMENT)
CAS:109125-51-1
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INGESTION:THE ORAL LDL0 FOR RATS IS
>5000MG/KG. MUTAGENESIS:NEGATIVE IN THE AMES TEST.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:MINIMAL IRRITATION TO RESPIRATORY TRACT MAY
OCCUR AS WITH EXPOSURE TO ANY NON-TOXIC DUST.
Medical Cond Aggravated by Exposure:ACCUMULATION OF DUST IN THE
RESPIRATORY SYSTEM.
======================= First Aid Measures =======================
First Aid:EYES:IN CASE OF CONTACT, IMMEDIATELY FLUSH WITH WATER FOR AT
LEAST 15 MINUTES. INHAL:REMOVE TO FRESH AIR. IF EFFECTS OCCUR,
CONSULT LOCAL MEDICAL PERSONNEL. SKIN:FLUSH W/COPIOUS AMOUNTS OF
WATER. CALL MD. . INGEST:CALL MD IMMEDIATELY.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER FOG, FOAM, CO2, OR DRY CHEMICALS.
Fire Fighting Procedures:NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NOT A FIRE HAZARD BUT CAN BURN IN A FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP OR CLEAR UP WITH A VACUUM CLEANER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED UNDER NORMAL USE.NIOSH/MSHA
APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:NONE
Other Protective Equipment:NONE REQUIRED UNDER NORMAL USE.
Work Hygienic Practices:INHALATION SHOULD BE AVOIDED.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:1.12(H20=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:FINE BLACK POWDER, ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:CO, CO2 AND NOX.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE OR DUMP UNDER THE CONDITIONS WHICH
MEET ALL FEDERAL, STATE AND LOCAL ENVIRONMENTAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TYPE III
CAGE:FO784
CAGE:1AM56
CAGE:FO784
============= Composition/Information on Ingredients =============
Ingred Name:MELAMINE, POLYMER W/FORMALDEHYDE
CAS:9003-08-1
RTECS #:OS1140000
Fraction by Wt: 70%
Ingred Name:CELLULOSE (PAPER FIBER)
CAS:9004-34-6
RTECS #:FJ5691460
Fraction by Wt: 28%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3; 9192
Ingred Name:PIGMENT
Fraction by Wt: <2%
Other REC Limits:10 MG/CUM (DUST)
Ingred Name:ADDITIVES
Fraction by Wt: <2%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN: IRRITATION.
INHALATION/INGESTION: LOW ORDER OF ACUTE TOXICITY.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES/SKIN: IRRITATION. INHALATION/INGESTION:
LOW ORDER OF ACUTE TOXICITY.
======================= First Aid Measures =======================
First Aid:EYES/SKIN: FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MINS.
INHALATION/INGESTION: OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:CO2, DRY CHEMICALS & WATER FOG
Fire Fighting Procedures:DON'T USE HIGH PRESSURE WATER STREAM. WATER
MAY USED TO COOL CLOSED CONTAINERS. USE FOG NOZZLES.
Unusual Fire/Explosion Hazard:HIGH DUST CONCENTRATE COULD FORM
EXPLOSIVE MIXTURE W/AIR.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP & PLACE WASTE IN DISPOSAL CONTAINER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN CLOSED PROPERLY LABELED
CONTAINERS IN COOL & VENTILATED AREA. DON'T TRANSFER TO UNMARKED
CONTAINERS.
Other Precautions:KEEP AWAY FROM HEAT, SPARKS, OPEN FLAME & OXIDIZING
AGENTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATORY PROTECTION
IN COMPLIANCE W/OSHA REGULATIONS. USE RESPIRATOR HOOD IF NECESSARY.
Ventilation:PROVIDE LOCAL EXHAUST/MECHANICAL VENTILATION TO KEEP <TLV.
Other Protective Equipment:EXPLOSION-PROOF EQUIPMENT MAY BE NECESSARY
IF AIRATED OR AIRVEYED.
Work Hygienic Practices:EXERCISE REASONABLE CARE & CAUTION. CLEAN UP &
WASH AFTER USING. MAINTAIN NORMAL GOOD HOUSEKEEPING FOR CONTROL OF
DUST.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Spec Gravity:1.5
Appearance and Odor:MULTICOLORED GRANULES W/SLIGHT PLASTIC ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS
Stability Condition to Avoid:OPEN FLAME, SPARKS & HOT SURFACES
Hazardous Decomposition Products:SMOKE, CO2 & CO
==================== Disposal Considerations ====================
Waste Disposal Methods:LANDFILL IN ACCORDANCE W/LOCAL, STATE, & FEDERAL
REGULATIONS. DON'T TRANSFER TO UNMARKED CONTAINERS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:NOX RUST 509
Preparer's Name:J KUKSUK
CAGE:02847
CAGE:02847
CAGE:0YMU2
CAGE:6X798
============= Composition/Information on Ingredients =============
Ingred Name:PETROLEUM OIL (SEVERELY SOLVENT REFINED &/OR SEVERELY
HYDROTREATED).
Fraction by Wt: 55-65%
Other REC Limits:NONE RECOMMENDED
ACGIH TLV:5 MG/M3
Ingred Name:PETROLEUM HYDROCARBON (PETROLATUM).
CAS:8009-03-8
Fraction by Wt: 25-30%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3 FUMES
Ingred Name:PARAFFIN WAX
CAS:8002-74-2
RTECS #:RV0350000
Fraction by Wt: 3-6%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:2 MG/M3 (FUME)
ACGIH TLV:2 MG/M3 (FUME)
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EXCESSIVE INHAL MAY PRODUCE
DIZZINESS, NAUSEA, HEADACHE, INCOORDINATION. MAY CAUSE REVERSIBLE
EYE & SKIN IRRIT. PROLONGED SKIN EXPOSURE MAY CAUSE DERMITITIS OR
OIL ACNE. BREATHING MISTS MAY CAU SE DIZZINESS OR PULMONARY IRRIT.
Medical Cond Aggravated by Exposure:EXPOSURE MAY AGGRAVATE PRE-EXISTING
RESPIRATORY OR SKIN PROBLEMS.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. CONSULT PHYSICIAN. IF BREATH
DIFFICULT GIVE OXYGEN. NOT BREATH, GIVE ARTIF RESP. EYES: FLUSH
IMMED W/RUNNING WATER >15 MINS. SEEK MED ATTN IMMED. SKIN: WASH
W/SOAP & WATER. REMOVE CONTAM CLOTH/SHOES. INGEST:DONTINDUCE
VOMIT. CALL DR. IF VOMITING SPONTANEOUSLY KEEP HEAD BELOW HIPS TO
PREVENT ASPIRATION OF LIQUID INTO LUNGS.
===================== Fire Fighting Measures =====================
Flash Point:>300F,>149C
Extinguishing Media:DRY CHEMICAL, CARBON DIOXIDE, WATER SPRAY, OR
REGULAR FOAM, FOG.
Fire Fighting Procedures:PRESSURE SCBA/PROTECTIVE CLOTHING. (LIMITED
PROT). EVAC AREA. STAY UPWIND/OUT OF LOW AREA. NOTIFY AUTHORITIES
OF RUNOFF.MOVE CNTNR FROM FIRE AREA IF SAFE.*
Unusual Fire/Explosion Hazard:KEEP AWAY FROM IGNITS. VAPORS MAY TRAVEL
TO IGNIT SOURCE & FLASHBACK. CNTNR MAY EXPLODE IN HEAT/FIRE. VAPOR
EXPLOSION HAZ INDOORS/OUTDOORS/SEWERS.
================== Accidental Release Measures ==================
Spill Release Procedures:SHUT OFF IGNITION SOURCES. NO FLARES, SMOKING,
FLAMES IN HAZARD AREA. STOP LEAK IF SAFE. LG SPILLS: DIKE FAR AHEAD
OF SPILL. SM SPILLS: TAKE UP W/SAND/OTHER NONCOMBUSTIBLE ABSORBENT.
PLACE IN CONTAINE RS FOR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, WELL VENTILATED AREA.
NO FLAME, SPARK, HOT SURFACES. DONT FLAME CUT/WELD ON/NEAR CNTNR.
EMPTY CNTNRS HAZARDOUS.
Other Precautions:NEVER WEAR CONTAM CLOTHING. LAUNDER BEFORE REWEARING.
DISCARD OIL SOAKED SHOES. WASH W/SOAP/WATER AFTER USE/BEFORE
SMOKING/EATING. AVOID EXCESSIVE SKIN CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED RESPIRATOR FOR ORGANIC VAPOR AND
MIST CONTROL EXPOUSRE WHERE VENTILATION IS INADEQUATE.
Ventilation:GENERAL AND LOCAL EXHAUST.
Other Protective Equipment:IF SPLASHING IS ANTICIPATED, WEAR RUBBER
APRON/BOOTS/OTHER PROTECTIVE EQPMT TO MINIMIZE CONTACT.
Supplemental Safety and Health
* USE WATER ON CNTNR SIDES EXPOSED TO FIRE UNTIL WELL AFTER FIRE IS
OUT. STAY AWAY FROM ENDS OF TANKS. USE UNMANNED HOSE HOLDER/MONITOR
NOZ FOR MASSIVE FIRE IN CARGO AREA. WITHDRAW IMMED IF RISING SOU ND
FROM VENTING SAFETY DEVICE OR DISCOLORATION OF TANK.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>300F,>149C
Vapor Pres:<1
Vapor Density:>1
Spec Gravity:0.9
pH:NA
VOC Grams/Liter:.8
Evaporation Rate & Reference:>1 (BU AC=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:DARK AMBER, SOFT WAXY SOLID, PETROLEUM OIL ODOR.
Percent Volatiles by Volume:<0.5
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, OXIDIZING AGENTS.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
OXIDES OF SULFUR, MISC HYDROCARBONS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH STATE LOCAL AND
FEDERAL REGULATIONS. MATERIALS MAY BECOME A HAZARDOUS WASTE THROUGH
USE. IF PERMITTED, INCINERATION MAY BE PRACTICED.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:953-506, TEFLON FINISH
CAGE:18873
CAGE:18873
============= Composition/Information on Ingredients =============
Ingred Name:SUPP DATA:FROM SMOKING TOBACCO/CIGARETTES CONTAMD
W/FLUOROCARBON DURING HNDLING/FROM BRTHG VAPS EMITTED DURING (ING
14)
RTECS #:9999999ZZ
Ingred Name:ING 13:BAKIN. HYDROGEN FLUORIDE IS TOX & CAN CAUSE SKIN &
EYE IRRIT.HIGH CONC CAN CAUSE LUNG DAM,PULM EDEMA/BURNS(ING 15
RTECS #:9999999ZZ
Ingred Name:ING 14:SOME VEGETATION IS PARTICULARLY SENSIT TO DAM BY HF
& ATTN MUST BE GIVEN TO EXHST LOCATIONS. CHRONIC:RPTS (ING 16
RTECS #:9999999ZZ
Ingred Name:ING 15:HAVE ASSOC RPTD & PRLNGD OVEREXP TO SOLV W/PERM
BRAIN & NERV SYS DAM.MICA LUNG DISEASE. N-METHYL-2-(ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16:PYROLIDONE, OXYGENATED NITROGEN POLYMER, FURFURYL
ALCOHOL & IRON OXIDE:MAY CAUSE IRRIT OF MUC MEMB.(ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17:TRIETHYLAMINE:UPPER RESP/LUNG IRRIT W/COUGH, DFCLTY
BRTHG, SHORTNESS OF BREATH.
RTECS #:9999999ZZ
Other REC Limits:NONE SPECIFIED
Ingred Name:HAZ DECOMP PRODS:OXIDES OF HEAVY METALS REPROTED IN
INGREDIENTS. TEFLON DECOMP PRODUCTS.
RTECS #:9999999ZZ
Other REC Limits:NONE SPECIFIED
Ingred Name:FLUOROPOLYMER SOLIDS
Ingred Name:GLYCOLS,POLYETHYLENE,MONO((1,1,3,3-TETRAMETHYL
BUTYL)PHENYL) ETHER; (OCTYLPHENOXYPOLY ETHOXYETHANOL NONIONIC
SURFACTANT)
CAS:9036-19-5
RTECS #:MD0907600
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:2-PYRROLIDINONE, 1-METHYL-; (N-METHYL-2-PYROLIDONE). VP:
0.3.
CAS:872-50-4
RTECS #:UY5790000
Other REC Limits:25 PPM (MFR)
Ingred Name:SILICATE, MICA; (MICA)
CAS:12001-26-2
RTECS #:VV8760000
OSHA PEL:20 MPPCF
ACGIH TLV:3 MG/M3 RDUST; 9293
Ingred Name:NON HAZARDOUS PIGMENT
Ingred Name:OXYGENATED NITROGEN POLYMER
Ingred Name:ETHANOL, 2-(DIETHYLAMINO)-; (DIETHYLAMINOETHANOL). VP: 1.
CAS:100-37-8
RTECS #:KK5075000
OSHA PEL:10 PPM, S
ACGIH TLV:10 PPM, S
Ingred Name:TRIETHYLAMINE. VP: 52.
CAS:121-44-8
RTECS #:YE0175000
OSHA PEL:25 PPM/15 STEL
ACGIH TLV:10 PPM/15 STEL; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:FURFURYL ALCOHOL. VP: 1.
CAS:98-00-0
RTECS #:LU9100000
OSHA PEL:S, 50 PPM/15 STEL
ACGIH TLV:S,10 PPM/15STEL;9293
Ingred Name:SILICA GEL; (AMORPHOUS SILICA)
CAS:112945-52-5
RTECS #:VV7310000
Other REC Limits:6 MG/M3 (MFR)
OSHA PEL:6 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:IRON (III) OXIDE; (IRON OXIDE)
CAS:1309-37-1
RTECS #:NO7400000
OSHA PEL:10 MG/M3 (FE)
ACGIH TLV:5 MG/M3(FE),B2; 9293
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL:VAPS MAY CAUSE NOSE &
THROAT IRRIT.MAY CAUSE NERVS SYS DEPRESS CHARACTERIZED BY THE
FOLLOWING PROGRESSIVE STEPS:HDCH, DIZZ, NAUS, STAGGERING GAIT,
CONFUSION, UNCON. EYE: MAY CAUSE IRRIT/BU RNING.
OCTYLPHENOXYPOLYETHOXYETHANOL NONIONIC SURFACTANT,
DIETHYLAMINOETHANOL AND TRIETHYLAMINE:CORR & PERM(EFTS OF OVER
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:INJURY. N-METHYL-2-PYROLIDONE &
OXYGENATED NITROGEN POLYMER:DISCOMFORT, TEARING, BLURRED VISION.
FURFURYL ALCOHOL:CORNEAL OPACITY.SKIN:RPTD/PRLNGD LIQ CONT MAY
CAUSE IRRIT W/RASH, DISCOMFORT & DERM. TRIETHYLAMINE:BURNS.
FURFURYL ALCOHOL: ALLERGIC RASH, ITCHING, SWELLING. FURFURYL
ALCOHOL: CAN BE ABSORBED(SUPP)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE ARTIFICIAL
RESPIRATION, PREFERABLY MOUTH-TO-MOUTH. IF BREATHING DIFFICULTY
PERSISTS/OCCURS LATER, CONSULT MD. EYE: IMMEDIATELY FLUSH WITH
PLENTY OF WA TER FOR AT LEAST 15 MINUTES, CONTACT MD. SKIN: WASH
WITH SOAP AND WATER. IF IRRITATION OCCURS, CONTACT MD. INGEST: CALL
MD IMMEDIATELY AND HAVE NAMES OF INGREDIENTS AVAILABLE.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:>140F,>60C
Lower Limits:0.90%
Upper Limits:6.90%
Extinguishing Media:FOAM CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . WATER FROM FOG NOZZLES MAY BE USED TO COOL
CLOSED CONTAINERS TO PREVENT PRESSURE BUILD-UP.
Unusual Fire/Explosion Hazard:WHEN HEATED >FL PT, EMITS FLAMM VAPS
WHICH, WHEN MIXED W/AIR, CAN BURN/BE EXPLO.FINE MISTS/SPRAYS MAY BE
FLAMM @ TEMPS 120F.
Other Precautions:EXPLO REACTION MAY OCCUR >796F W/FINELY DIVIDED
FLUOROCARBON & METAL POWDER (ALUMINUM/MAGNESIUM). OPERATIONS SUCH
AS GRINDING, BUFFING OR GRIT BLASTING MAY GENERATE SUCH MIXTURES.
KEEP WET. USE ADEQUA TE VENTILATION TO CONTROL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:DO NOT BREATHE VAPS/MISTS. WEAR PROPERLY FITTED
VAP/PARTICULATE RESPIRATOR APPRVD BY NIOSH/MSHA (TC-23C) FOR USE
W/PAINTS DURING APPLICATN & UNTIL ALL VAPS & SPRAY MIST ARE EXHSTD.
FOLLOW RESPIRATOR M FR'S DIRECTIONS FOR RESPIRATOR USE.
Ventilation:PROVIDE SUFFICIENT VENT IN VOL & PATTERN TO KEEP CONTAM <
APPLIC OSHA REQMTS.BAKING OVEN MUST BE PROPERLY VENTILATED.
Other Protective Equipment:COVERALLS.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING AND BEFORE
EATING AND SMOKING.
Supplemental Safety and Health
% VOLAT:52.8-76.6% (WT). EXPLO HAZ:RELEASED DURING A FIRE. HLTH
HAZ:THRU SKIN IN HARMFUL AMTS. INGEST:GI DISTRESS. TEFLON DECOMP
PRODS CAN CREATE INFLUENZA-LIKE POLMYMER FUME FEVER. SYMPS DO NOT
ORDIN ARILY OCCUR UNTIL SEVERAL HRS AFTER EXPOS & PASS W/IN 36-48
HRS.EFTS ARE NOT CUMULATIVE.EXPOS USUALLY RSLTS FROM(ING 13)
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:>190F,>88C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:1.1-1.3
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:SLIGHT
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:SUPDAT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE REASONABLY FORSEEABLE.
Stability Condition to Avoid:DO NOT EXCEED RECOMMENDED BAKING TEMPS.
Hazardous Decomposition Products:AT TEMPS >400C (750F) SMALL AMOUNTS OF
HYDROGEN FLUORIDE CAN BE EVOLVED; AMOUNTS INCREASE AS TEMP
INCREASES. (ING 19)
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT ALLOW MATERIAL TO CONTAMINATE GROUND
WATER SYSTEMS. INCINERATE ABSORBED MATERIAL I/A/W FEDERAL, STATE
AND LOCAL REQUIREMENTS. DO NOT INCINERATE IN CLOSED CONTAINERS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:BACTIMOS BRIQUETS
CAGE:6R717
Contract Num:SP0450-99-MC223
CAGE:0TNN7
CAGE:6R717
============= Composition/Information on Ingredients =============
Ingred Name:NON HAZARDOUS INGREDIENTS
= Wt:100.
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE AND CHRONIC - NONE KNOWN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:NO EXPOSURE HAZARD
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:NONE REQUIRED.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WATER, CONVENTIONAL FIRE EXTINGUISHERS.
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN UP WITH SOAP AND WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE.
Other Precautions:RESEAL OPENED CONTAINERS AFTER PARTIAL USE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NEEDED
Ventilation:NONE NEEDED
Other Protective Equipment:WEAR NORMAL WORK CLOTHING.
Work Hygienic Practices:NO SPECIAL PRACTICES NEEDED.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:NONE
Spec Gravity:<1
Appearance and Odor:LIGHT BROWN DONUT-SHAPED DISKS; ESSENTIALLY
ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALKALINE CONDITIONS ABOVE PH 9 MAY DENATURE PRODUCT.
Stability Condition to Avoid:PROTECT BRIQUETS FROM MOISTURE DURING
STORAGE.
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:CONVENTIONAL TRASH REMOVAL AND LANDFILL.
===================== Regulatory Information =====================
Federal Regulatory Information:EPA REGISTRATION NUMBER: 6218-47
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Preparer's Name:DOD HMIS/DGSC-SSH
CAGE:JO772
CAGE:14153
CAGE:JO772
============= Composition/Information on Ingredients =============
Ingred Name:ASBESTOS, CHRYSOTILE
CAS:12001-29-5
RTECS #:CI6478500
OSHA PEL:0.2 FIBERS/CC
ACGIH TLV:2 FIBERS/CC; A1;9192
Ingred Name:ASBESTOS OVERALL COMPOSITION
RTECS #:9999999ZZ
Ingred Name:GENERIC "MSDS". SPECIFIC ASBESTOS TYPE NOT KNOWN. ONE
CITED IS ASSUMED. INFORMATION BASED ON SEGMENT "M" OF "DLSC TIR"
RTECS #:9999999ZZ
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: NO ACUTE EFFECTS ARE KNOWN;
CHRONIC: DUST FROM ABRASIVE ACTIONS(EG. CUTTING, MACHINING,
FILING, ETC.) MAYCONTAIN ASBESTOS FIBERS. CHRONIC OVEREXPOSURE
TO AIRBORNE FIBERS MAY LEAD TO ASBESTOSIS & MESOTHELIOMA.
SMOKINGCOMBINED W/FIBER INHALATION GREATLY INCREASES LUNG
CANCER RISK!
Explanation of Carcinogenicity:OVEREXPOSURE TO AIRBORNE CONCENTRATIONS
OF ASBESTOS MAY LEAD TO ASBESTOSIS AND MESOTHELIOMA.
Effects of Overexposure:INHAL: INHALATION OF AIRBORNE DUST CONTAINING
ASBESTOS FIBERS ON REPEATED EXPOSURE MAY CAUSE OR CAN LEAD TO
ASBESTOSIS/ MESOTHELIOMA; SKIN: N/K; EYE: POTENTIAL IRRITATION
FROM AIRBORNE DUST; INGEST: N/K.
Medical Cond Aggravated by Exposure:RESPIRATORY DEFICIENCIES DUE TO
REPEATED INHALATION OF AIRBORNE FIBERS.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. OBTAIN MEDICAL ADVICE; SKIN:
WASH EXPOSED AREA WITH SOAP & WATER; EYE: FLOOD W/ WATER. IF
IRRITATION OCCURS, GET MEDICAL ATTN; INGEST: CONSULT A
PHYSICIAN; OTHER: CHANGE CLOTHING AS REQUIRED TO AVOIDCARRYING
DUST PARTICLES INTO OTHER AREAS
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:MATERIAL IS NOT FLAMMABLE ; USE MEDIA APPROPRIATE
FOR SURROUNDING FIRE.
Fire Fighting Procedures:COMBUSTION PRODUCTS OF THIS MATERIAL MAY BE
TOXIC. USE A SELF-CONTAINED BREATHING APPARATUS WHEN FIGHTING FIRES
INVOLVING CHEMICAL PRODUCTS.
Unusual Fire/Explosion Hazard:NONE KNOWN
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION. VACUUM OR WET
CLEAN IF DUST IS INVOLVED. ANY VACUUM SYSTEM SHOULD BE EQUIPPED W/
AN OUTLET "HEPA" FILTER TO PREVENT REINTRODUCING ASBESTOS FIBERS TO
THE ATMOSPHERE.
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLE IN A MATTER TO MINIMIZE
FORMATION OR RETENTION OF AIRBORNE DUST. USE PROPER PERSONAL
PROTECTION FOR TASK AT HAND. CHECK W/YOUR SAFETY OFFICE!!!
Other Precautions:AS MANUFACTURED, LOCKED-IN ASBESTOS DOES NOT PRESENT
A HAZARD. ONLY WHEN THE ITEM IS SUBJECTED TO ABRASIVE ACTIONS &
DUST IS GENERATED, THEN ASBESTOS FIBERS MAY BE RELEASED & BECOME
AIRBORNE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF EXPOSURES EXCEED ESTABLISHED LIMITS, A
NIOSH/MSHA APPROVED RESPIRATOR FOR ASBESTOS SHOULD BE USED.
CONSULT YOUR SAFETY OFFICE/IH PERSONNEL FOR GUIDANCE FOR THE TASK
AT HAND.
Ventilation:LOCAL EXHAUST IS RECOMMENDED IN SITUATIONS WHERE DUST IS
GENERATED BY ABRASIVE ACTIONS, ABRASION OR OTHER MEANS.
Other Protective Equipment:AS REQUIRED FOR TASK AT HAND, AND THE
GUIDANCE SET FORTH BY YOUR SAFETY OFFICE OR IH PERSONNEL
Work Hygienic Practices:DONOT INHALE DUST CREATED BY ABRADING ACTIONS.
USE FULL PROTECTION AGAINST AIRBORNE FIBERS. AVOID AIRBORNE DUST
CREATION
Supplemental Safety and Health
GENERIC "MSDS" CREATED FOR "NSN" IDENTIFIED BY "DISC" AS CONTAINING
ASBESTOS.WHEN A MANUFACTURER'S SPECIFIC "MSDS" IS PROVIDED FOR
MATERIAL PROCURED UNDER THIS NSN, THIS GENERIC "MSDS" WILL BE
REMOVED.
================== Physical/Chemical Properties ==================
HCC:T6
Evaporation Rate & Reference:NONE
Solubility in Water:NOT SOLUBLE
Appearance and Odor:MANUFACTURED COMMODITY DESCRIBED BY LOGISTICS:
"ITEM-NAME"
Percent Volatiles by Volume:NONE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:NONE KNOWN
==================== Disposal Considerations ====================
Waste Disposal Methods:DUST SHOULD BE HANDLED AS A HAZARDOUS AIR
POLLUTANT I/A/W 40CFR61 SUBPART "M" PERTAINING TO ASBESTOS. USE
LANDFILLS APPROVED FOR ASBESTOS DISPOSAL. NOTE IF ITEM UNDER
CONSIDERATION FOR DISPOSAL IS "FRIABLE OR NON-FRIABLE".
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:371493, CORAY 46
CAGE:1PWD8
Contract Num:SP0450-01-M-LH93
CAGE:82956
Contract Num:SP0450-00-M-C589
CAGE:1MDA6
CAGE:80738
CAGE:1PWD8
CAGE:0TS34
============= Composition/Information on Ingredients =============
Ingred Name:DISTILLATES (PETROLEUM), HYDROTREATED HEAVY NAPHTHENIC
CAS:64742-52-5
RTECS #:PY8035000
= Wt:100.
OSHA PEL:5 MG/M3
OSHA STEL:10 MG/M3
ACGIH TLV:5 MG/M3
ACGIH STEL:10 MG/M3
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL, RAT, LD50: >5 G/KG
Reports of Carcinogenicity:NTP:UNKNOWN IARC:NO OSHA:NO
Health Hazards Acute and Chronic:HEALTH STUDIES HAVE SHOWN THAT MANY
PERTOLEUM HYDROCARBONS AND SYNTHETIC LUBRICANTS POSE POTENTIAL
HUMAN HEALTH RISKS WHICH MAY VARY FROM PERSON TO PERSON. AS A
PRECAUTION, EXPOSURE TO LIQUIDS, VAPORS , MISTS OR FUMES SHOULD BE
MINIMIZED. SKIN CONTACT: PROLONGED OR REPEATED CONTACT REMOVES SKIN
OILS, LEADING TO IRRITATION AND DERMATITIS. EYE CONTACT: MAY CAUSE
IRRITATION. INGESTION: PRODUCT HAS A L OW ORDER OF ACUTE ORAL AND
DERMAL TOXICITY. MINUTE AMOUNTS ASPIRATED INTO LUNGS DURING
INGESTION OR VOMITING MAY CAUSE MILD TO SEVERE PULMONARY INJURY AND
POSSIBLY DEATH.
Explanation of Carcinogenicity:THIS PRODUCT DOES NOT REQUIRE A CANCER
HAZARD WARNING.
Effects of Overexposure:EYE CONTACT: IRRITATION. SKIN CONTACT:
IRRITATION, DERMATITIS. ASPIRATED INTO THE LUNGS DURING INGESTION
OR VOMITING MAY CAUSE MILD TO SEVERE PULMONARY INJURY AND POSSIBLE
DEATH.
Medical Cond Aggravated by Exposure:NONE RECOGNIZED.
======================= First Aid Measures =======================
First Aid:EYE CONTACT: FLUSH WITH WATER FOR 15 MINUTES. IF IRRITATION
PERSISTS, CALL A PHYSICIAN. SKIN CONTACT: REMOVE CONTAMINATED
CLOTHING. AND LAUNDER BEFORE REUSE. WASH SKIN WITH SOAP AND WATER.
IF PRODUCTINJECTED INTO THE SKIN, THE INDIVIDUAL SHOULD BE
EVALUATED BY PHYSICIAN AS A SURGICAL EMERGENCY. INHALATION: IF
OVERCOME BY VAPOR FROM HOT PRODUCT, MOVE TO FRESH AIR. GET MEDICAL
ATTENTION. IF NOT BR EATHING, GIVE RESUSCITATION; IF BREATHING IS
DIFFICULT GIVE OXYGEN. INGESTION: DO NOT INDUCE VOMITING, CALL A
PHYSICIAN IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:>171.C, 339.8F
Autoignition Temp:>343.C, 649.4F
Lower Limits:ND
Upper Limits:ND
Extinguishing Media:FOAM, WATER SPRAY (FOG), DRY CHEMICAL, CARBON
DIOXIDE, AND VAPORIZING LIQUID TYPE EXTINGUISHING AGENTS MAY ALL BE
SUITABLE FOR EXTINGUISHING FIRES INVOLVING THIS TYPE OF PRODUCT.
Fire Fighting Procedures:USE WATER SPRAY, DRY CHEMICAL, FOAM, OR CARBON
DIOXIDE TO EXTINGUISH THE FIRE. USE WATER TO KEEP FIRE-EXPOSED
CONTAINERS COOL. IF A LEAK OR SPILL HAS NOT IGNITED, USE WATER
SPRAY TO DISPERSE VAPORS A ND TO PROVIDE PROTECTION FOR PERSONS
ATTEMPTING TO STOP A LEAK. WATER SPRAY MAY BE USED TO FLUSH SPILLS
FROM EXPOSURES.
Unusual Fire/Explosion Hazard:MINIMIZE BREATHING OF GASES, VAPOR,
FUMES, OR DECOMPOSITION PRODUCTS. USE SUPPLIED-AIR BREATHING
EQUIPMENT FOR ENCLOSED OR CONFINED SPACES OR AS OTHERWISE NEEDED.TO
PREVENT FIRE OR EXPLOSION RISK FRO M STATIC ACCUMULATION AND
DISCHARGE, EFFECTIVELY BOND AND/OR GROUND PRODUCT TRANSFER SYSTEM.
================== Accidental Release Measures ==================
Spill Release Procedures:RECOVER FREE PRODUCT. ADD SAND, EARTH OR OTHER
SUITABLE ABSORBENT TO SPILL AREA. MINIMIZE BREATHING VAPORS.
MINIMIZE SKIN CONTACT. OPEN ALL WINDOWS AND DOORS. KEEP PRODUCT OUT
OF SEWERS AND WATERCORUS ES BY DIKING OR IMPOUNDING. ADVISE
AUTHORITIES IF PRODUCT HAS ENTERED OR MAY ENTER SEWERS,
WATERCOURSES, OR EXTENSIVE LAND AREAS. ASSURE CONFIRMITY WITH
APPLICABLE GOVERNMENTAL REGULATIONS.
======================Handling and Storage ======================
Handling and Storage Precautions:USE PRODUCT WITH CAUTION AROUND HEAT,
SPARKS, STATIC ELECTRICITY, FLAMES. KEEP CONTAINERS CLOSED WHEN NOT
IN USE. DO NOT STORE NEAR HEAT, SPARKS, FLAME, OR STRONG OXIDANTS.
IN ORDER TO PREVENT FIRE OR EXPLOSION HAZARDS, USE APPROPRIATE
EQUIPMENT.
Other Precautions:DO NOT REFILL OR CLEAN CONTAINERS SINCE RESIDUE IS
DIFFICULT TO REMOVE. "EMPTY" DRUMS SHOULD BE COMPLETELY DRAINED,
PROPERLY BUNGED AND PROMPTLY RETURNED TO A DRUM RECONDITIONER. ALL
OTHER CONTAINERS SHOULD BE DISPOSED OF IN AN ENVIRONMENTALLY SAFE
MANNER AND IN ACCORDANCE WITH GOVERNMENTAL REGULAT IONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE SUPPLIED-AIR RESPIRATORY PROTECTION IN
CONFINED OR ENCLOSED SPACES, IF NEEDED.
Ventilation:USE LOCAL EXHAUST IF NECESSARY. PROVIDE ADQUATE VENTILATION
TO PREVENT EXCEEDING RECOMMENDED EXPOSURE LIMITS OR BUIDUP OF
EXPLOSIVE CONCENTRATIONS.
PROLONGED/REPEATED SKIN CONTACT.
OCCUR.
Other Protective Equipment:USE CHEMICAL-RESISTANT APRON OR OTHER
IMPERVIOUS CLOTHING, IF NEEDED, TO AVOID CONTAMINATING REGULAR
CLOTHING, WHICH COULD RESULT IN PROLONGED OR REPEATED SKIN CONTACT.
Work Hygienic Practices:MINIMIZE BREATHING VAPOR, MIST OR FUMES. AVOID
PROLONGED OR REPEATED CONTACT WITH SKIN. REMOVE CONTAMINATED
CLOTHING: LAUNDER OR DRY-CLEAN BEFORE RE-USE. REMOVE CONTAMINATED
SHOES .
Supplemental Safety and Health
THOROUGHLY CLEAN SHOES BEFORE REUSE. DISCARD IF OIL-SOAKED. CLEANSE
SKIN THOROUGHLY AFTER CONTACT, BEFORE BREAKS AND MEALS, AND AT END
OF WORK PERIOD. PRODUCT READILY REMOVED FROM SKIN BY WATERLESS HA
ND CLEANERS FOLLOWED BY WASHING THROUGHLY WITH SOAP AND WATER.
================== Physical/Chemical Properties ==================
HCC:V6
Boiling Pt:>274.C, 525.2F
B.P. Text:IBP
Melt/Freeze Pt:M.P/F.P Text:ND
Vapor Pres:<0.01MM HG @20C
Vapor Density:>5 (AIR=1)
Spec Gravity:0.94 @ 13.6C
pH:NEUTRAL
Viscosity:231 SUS @ 100F
Evaporation Rate & Reference:<0.01(N-BUTYL ACETATE=1)
Solubility in Water:<0.1% @77F
Appearance and Odor:CLEAR LIQUID, LIGHT YELLOW TO CLEAR COLOR, MILD,
BLAND PETROLEUM ODOR.
Percent Volatiles by Volume:NEGLIGIBLE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDANTS SUCH AS LIQUID CHLORINE, CONCNTRATED OXYGEN, SODIUM
HYPOCHLORITE, CALCIUM HYPOCHLORITE, ETC., AS THIS PERSENTS A
SERIOUS EXPLOSION HAZARD.
Stability Condition to Avoid:THIS PRODUCT IS STABLE AND WILL NOT REACT
WITH VIOLENTLYWATER
Hazardous Decomposition Products:FUMES, SMOKE, CARBON MONOXIDE,
ALDEHYDES AND OTHE DECOMPOSITION PRODUCTS, IN CASE OF INCOMPLETE
COMBUSTION.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
=================== Toxicological Information===================
Toxicological Information:PROLONGED OVEREXPOSURE TO OIL MISTS MAY
RESULT IN DROPLET DEPOSITION, OIL GRANULOMA FORMATION, INFLAMMATION
AND INCREASED INFECTION. BASED ON OSHA, PRODUCT DOES NOT REQUIRE A
CANCER HAZARD WARNING. S INCE PRODUCT IS FORMULATED FROM BASE
STOCK WHICH ARE SEVERELY HYDROTREATED, SEVERELY SOLVENT EXTRACTED,
AND/OR PROCESSED BY MILD HYDROTREATEMNT AND EXTRACTION.
ALTERNATIVELY, IT MAY CONSIST OF COMPONE NTS NOT AFFECTED BY IARC
CRITERIA, SUCH AS ATMOSPHERIC DISTILLATES OR SYNTHETICALLY DERIVED
MATERIALS, AND IS NOT CHARACTERIZED BY CURRENT IARC CRITERIA.
PRODUCT IS JUDGED TO BE NEITHER A "CORROSION" NOR AN "IRRITANT" BY
OSHA CRITERIA.
===================== Ecological Information =====================
Ecological:CLEAN WATER ACT OIL POLLUTION ACT: THIS PRODUCT MAY BE
CLASSIFIED AS AN OIL UNDER SECTION 311 OF THE CLEAN WATER ACT, AND
UNDER THE OIL POLLUTION ACT. DISCHARGES OR SPILLS INTO OR LEADING
TO SURFACE W ATERS THAT CAUSE A SHEEN MUST BE REPORTED TO THE
NATIONAL RESPONSE CENTER (1-800-424-8802).
==================== Disposal Considerations ====================
Waste Disposal Methods:OPTIONS FOR DISPOSAL OF THIS PRODUCT MAY DEPEND
ON THE CONDITIONS UNDER WHICH IT WAS USED. TO DETERMINE THE PROPER
METHOD OF DISPOSAL, REFER TO RCRA 40 CFR 261, AS WELL AS FEDERAL
EPA AND STATE AND LO CAL REQUIREMENTS.
=================== MSDS Transport Information ===================
Transport Information:FOR FUTHER INFORMATION RELATIVE TO SPILLS
RESULTING FROM TRANSPORTATION INCIDENTS, REFER TO LATEST DEPARTMENT
OF TRANSPORTATION EMERGENCY RESPONSE GUIDEBOOK FOR HAZARDOUS
MATERIALS INCIDENTS. U.S. DOT HAZARDOUS MATERIALS SHIPPING
DESCRIPTION: NOT REGULATED. OSHA REQUIRED LABEL INFORMATION: IN
COMPLIANCE WITH HAZARD AND RIGHT-TO-KNOW REQUIREMENTS, WHERE
APLICABLE OSHA HAZARD WARNINGS MAY BE FOUND O N THE LABEL, BILL OF
LADING OR INVOICE ACCOMPANYING THIS SHIPMENT. NOTE: PRODUCT LABEL
MAY CONTAIN NON-OSHA RELATED INFORMATION ALSO.
===================== Regulatory Information =====================
SARA Title III Information:THRESHOLD PLANNING QUANTITY (TPQ), EPA
REGULATION 40 CFR 355 (SARA SECTIONS 301-304): NO TPQ FOR PRODUCT
OR ANY CONSTITUENT GREATER THAN 1% OR 0.1% (CARCINOGEN). TOXIC
CHEMICAL RELEASE REPORTING, EPA REGULATION 40 CFR 372 (SARA
SECTION 313): NO TOXIC CHEMICAL IS PRESENT GREATER THAN 1% OR 0.1%
(CARCINOGEN). HAZARDOUS CHEMICAL REPORTING, EPA REGULATION 40 CFR
370 (SARA SECTIONS 311-312): EPA HAZARD CLASSIFICATION CODE: NOT
APPLICABLE.
Federal Regulatory Information:ALL COMPONENTS OF THIS PRODUCT ARE
LISTED ON THE U.S. TSCA INVENTORY. THIS PRODUCT, AS MANUFACTURED BY
EXXONMOBIL, DOES NOT CONTAIN POLYCHLORINATED BIPHENYLS (PCB'S).
HMIS HAZARD RATINGS: HEALTH: 1; F LAMMABILITY: 1; REACTIVITY: 0.
NFPA HAZARDRATINGS: HEALTH: 1; FLAMMIBILITY: 1; REACTIVITY: 0.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MIL-H-4600C AM2 ISO 46 HYD FLUID MACH TOOLS
Preparer's Name:RICHARD J. EBERHARDT
CAGE:8Y842
CAGE:8Y842
============= Composition/Information on Ingredients =============
Ingred Name:DISTILLATES, HYDROTREATED HEAVY PARAFFINIC
CAS:64742-54-7
RTECS #:PY8035500
Fraction by Wt: 90-100%
Other REC Limits:NONE SPECIFIED
OSHA PEL:300 PPM
ACGIH TLV:300 PPM
Ingred Name:OTHER COMPONENTS (TYPE NOT SPECIFIED)
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NOT SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:UNKNOWN Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:IRRITATION OF EYES, SKIN
RESPIRATORY OR G.I. TRACTS; CNS EFFECTS LIKE HEADACHE, DIZZINESS,
NAUSEA AND VOMITING. REDNESS OR BURNS OF EYES/SKIN POSSIBLE.
CHRONIC: DRYING OF SKIN. DEFATTING OR DERM ATITIS.
Explanation of Carcinogenicity:DATA PER MSDS
Effects of Overexposure:MAY CAUSE IRRITATION OF EYES, SKIN, RESPIRATORY
OR G. I. TRACTS. MAY CAUSE HEADACHE, DIZZINESS, NAUSEA, VOMITING OR
GI TRACT DISTURBANCES. POSSIBLE BURNS OR REDNESS OF EYES, CRACKING
OR DRYNESS OF SKI N.
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF AILMENTS
OR WITH A PRE-EXISTING DISEASE INVOLVING THE EYES, SKIN OR
RESPIRATORY TRACT MAY BE AT INCREASED RISK FORM EXPOSURE.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. RESUSCITATE IF NOT
BREATHING. GET MEDICAL ATTENTION. EYES: IMMEDIATELY FLUSH WITH
PLENTY OF WATER FOR 15 MINUTES HOLDING EYELIDS OPEN. GET MEDICAL
ATTENTION. SKIN: REM OVE CONTAMINATED CLOTHING. WASH WITH SOAP AND
WATER. IF IRRITATION PERSISTS, GET MEDICAL ATTENTION. INGESTION: DO
NOT INDUCE VOMITING. GIVE NOTHING BY MOUTH IF UNCONSCIOUS. GET
MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:392F,200C
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM OR DRY CHEMICAL
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NISOH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:CONTAINERS MAY EXPLODE DUE TO EXTREME
HEAT, FIRE OR EXCESSIVE HEAT MAY CAUSE PRODUCTION OF HAZARDOUS
DECOMPOSITION PRODUCTS.
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION. CONTAIN FREE
MATERIAL IF POSSIBLE. USE SUITABLE INERT ABSORBENT MATERIAL AND
RECOVER FOR PROPER DISPOSAL IN AN APPROVED CONTAINER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY, WELL VENTILATED
AREA. KEEP CONTAINERS TIGHTLY CLOSED WHEN NOT IN USE. PROTECT
CONTAINERS FROM PHYSICAL DAMAGE.
Other Precautions:DO NOT TAKE INTERNALLY. DO NOT BREATHE MIST. AVOID
PROLONGED OR REPEATED BREATHING OF VAPOR. AVOID CONTACT WITH EYES.
USE ADEQUATE VENTILATION. WASH THOROUGHLY AFTER HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR AS REQUIRED
IF ABOVE PEL/TLV OR SCBA IN AN ENCLOSED AREA.
Ventilation:LOCAL/GENERAL TO MAINTAIN PEL/TLV.
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER, WORK
CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING AND/OR
FOOTWEAR.
Supplemental Safety and Health
AVOID PROLONGED OR REPEATED EXPOSURE. DO NOT GET ON SKIN OR IN EYES. DO
NOT BREATH THE VAPORS OR MISTS. DO NOT USE CONTAMINATED CLOTHES.
PROPER FOOTWEAR REQUIRED.
================== Physical/Chemical Properties ==================
HCC:V6
Boiling Pt:B.P. Text:>572F,>300C
Vapor Pres:<0.01
Vapor Density:>1
Spec Gravity:0.874
Evaporation Rate & Reference:<1.0 ETHER =1
Solubility in Water:NIL
Appearance and Odor:AMBER OILY LIQUID, PETROLEUM ODOR
Percent Volatiles by Volume:NIL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH TEMPERATURES, SPARKS AND OPEN FLAMES
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE AND
OTHER UNIDENTIFIED COMPONENTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONSULT LOCAL AUTHORITIES. DISPOSAL MUST BE MADE
IN ACCORDANCE WITH ALL APPLICABLE FEDERAL, STATE AND LOCAL LAWS AND
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:11A TRANS KLEEN
Preparer's Name:A. B. REED
CAGE:SILOO
CAGE:050Q3
CAGE:SILOO
============= Composition/Information on Ingredients =============
Ingred Name:PETROLEUM MID-DISTILLATE
CAS:68476-34-6
Fraction by Wt: 55.0%
Other REC Limits:NONE RECOMMENDED
Ingred Name:XYLENES (O-,M-,P- ISOMERS) (SARA 313) (CERCLA)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 14.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/150STEL;9596
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SEC-BUTYL ALCOHOL (SARA 313)
CAS:78-92-2
RTECS #:EO1750000
Fraction by Wt: 7.5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:150 PPM
ACGIH TLV:100 PPM; 9596
Ingred Name:100 SUS PARAFFINIC OIL
CAS:64742-47-8
RTECS #:OA5504000
Fraction by Wt: 20.5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:TETRAHYDRONAPHTHALENE
CAS:119-64-2
RTECS #:QK3850000
Fraction by Wt: 1.9%
Other REC Limits:NONE RECOMMENDED
Ingred Name:2-BUTOXYETHANOL PHOSPHATE
CAS:78-51-3
RTECS #:KJ9800000
Fraction by Wt: 1.1%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:MAY CAUSE BURNING & IRRIT OF
EYE. SKIN CONTACT WILL CAUSE DRYNESS. INHAL OF MIST MAY CAUSE
BREATHING PROBLEMS. VAPORS MAY ALSO CAUSE HEADACHES OR NAUSEA.
CHRONIC:PROLONGED EXPOSURE TO SKIN MAY C AUSE DEVELOPMENT OF
DERMATITIS.
Explanation of Carcinogenicity:PER MSDS:CHEMICAL LISTED AS CARCINOGEN
OR POTENTIAL CARCINOGEN:NTP/IARC/OSHA:NO.
Effects of Overexposure:BURNING & IRRIT EYE. SKIN DRYNESS. BREATHING
PROBLEMS. HEADACHES & NAUSEA. DEVELOPMENT OF DERMATITIS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:IF SYMPTOMS PERSIST CALL PHYSICIAN. INHAL:REMOVE TO FRESH
AIR.APPLY ARTIFICIAL RESP IF NEEDED. EYE:FLUSH W/LARGE AMTS OF
WATER. SKIN:WASH W/WATER.REMOVE CONTAMINATED CLOTHING. INGEST:DO
NOT INDUCE VOM TING.CALL PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:75.0F,23.9C
Lower Limits:NA
Upper Limits:NA
Extinguishing Media:CO2, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:NONE SPECIFIED BY MANUFACTURER.
Unusual Fire/Explosion Hazard:TREAT AS OIL FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ANY SOURCE OF IGNITION, VENTILATE AREA.
DIKE AREA & PUMP INTO DRUMS OR AS ABSORBANT TO PICK UP.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL DRY AREA.
Other Precautions:KEEP CONTAINER CLOSED WHEN NOT IN USE. SPILLS SHOULD
BE KEPT OUT OF STREAMS OR WATER SUPPLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE SELF-CONTAINED BREATHING APPARATUS FOR
CONCENTRATION ABOVE TLV.
Ventilation:ADEQUATE TO MAINTAIN VAPOR CONCENTRATEION BELOW TLV.
Other Protective Equipment:OIL RESISTANT APRONS, BOOTS, ETC SHOULD BE
WORN IF OTHER PARTS OF BODY ARE SUBJECTED TO EXPOSURE.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER. HMIS:WASH HANDS
AFTER HANDLING.LAUNDRY CONTAMIN CLOTHING BEFORE REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:NA
Melt/Freeze Pt:M.P/F.P Text:NA
Decomp Temp:Decomp Text:NP
Vapor Pres:NA
Vapor Density:NA
Spec Gravity:0.8682
pH:NP
Evaporation Rate & Reference:NA
Solubility in Water:NEGLIGIBLE.
Appearance and Odor:LIGHT AMBER COLORED LIQUID, AROMATIC ODOR.
Percent Volatiles by Volume:79
Corrosion Rate:NP
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:SOURCES OF IGNITION.
Hazardous Decomposition Products:CO2, CARBON MONOXIDE (FIRE).
==================== Disposal Considerations ====================
Waste Disposal Methods:TREAT AS HAZ WASTE IN ACCORDANCE W/FED/STATE/LOC
REGULATIONS. CHEMS FOUND IN SEC 313 OF EPCRA SARA TITLE III & SUBJ
TO RELEASE INVENTORY REPORTING:XYLENE, SEC BUTYL ALCOHOL.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ROCKWELL 950 SEALANT(BULK GRADE)
CAGE:25203
CAGE:80318
CAGE:25203
============= Composition/Information on Ingredients =============
Ingred Name:POLYESTER RESIN CAS# N/R
85-90%
Ingred Name:TREATED CLAY CAS#54351-63-2
10-15%
Fraction by Wt: <1%
===================== Hazards Identification =====================
Effects of Overexposure:EYES:IRRIT.INGEST:IRRIT TO GI TRACT.INHAL:NONE
EXPECTED.SKIN:PRLG/RPTD CONT MAY IRRIT.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/ WATER FOR 15 MIN.CALL MD.SKIN:WASH W/ SOAP &
WATER.INHAL:NO PROBLEM UNDER NORMAL CONDITIONS.INGEST:CALL MD.
===================== Fire Fighting Measures =====================
Flash Point:>400F,>204 COC
Extinguishing Media:DRY CHEMICAL POWDER,CO*2,CHEMICAL FOAM
Fire Fighting Procedures:WEAR SCBA IN CONFINED AREA.TREAT AS BURNING
LIQUID.
Unusual Fire/Explosion Hazard:N/K(PER MANUFACTURER)
================== Accidental Release Measures ==================
Spill Release Procedures:RECOVER FREE MATERIAL.ADD SUITABLE ABSORBANT
TO SPILL ARE.CLEAN SPILL AREA W/ DETERGENT SOLUTION.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN SEALED CONTAINERS AWAY FROM
HEAT & STRONG OXIDIZERS
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NEEDED UNDER NORMAL CONDITIONS PER
MANUFACTURER.
Ventilation:USE ADEQUATE GENERAL OR MECHANICAL VENTILATION.
Other Protective Equipment:N/R PER MANUFACTURER.
Supplemental Safety and Health
MSDS PREP:85305.CALLED MFR:EMERGENCY NUMBER.SPEC:TYPE III
================== Physical/Chemical Properties ==================
HCC:V6
Vapor Pres:NIL
Spec Gravity:1.1
Evaporation Rate & Reference:NIL(ETHER=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:TAN,GREASE-LIKE.SLIGHT ODOR
Percent Volatiles by Volume:NIL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDANTS
Hazardous Decomposition Products:CARBON MONOXIDE,CARBON
DIOXIDE,ASPHYXIANTS
==================== Disposal Considerations ====================
Waste Disposal Methods:DIPSOSE WASTE IN APPROVED LANDFILL OR INCINERATE
IN ACCORDANCW W/ ALL FED,STATE,& LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:UV CURE ADHESIVE TYPE 10
CAGE:HO985
CAGE:HO985
CAGE:0PWA9
============= Composition/Information on Ingredients =============
Ingred Name:URETHANE DIMETHACRYLATE RESIN; (URETHANE METHACRYLATE
RESIN)
Fraction by Wt: 25-30%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SILANE, 3-(2,3-EPOXYPROPOXY)PROPYLTRIMETHOXY-; (SUBSTITUTED
SILANE)
CAS:2530-83-8
RTECS #:VV4025000
Fraction by Wt: 1-3%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:METHACRYLATE ESTER; (HIGH BOILING METHACRYLATE ESTER)
CAS:68586-19-6
Fraction by Wt: 50-55%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ACRYLIC ACID (SARA 313) (CERCLA)
CAS:79-10-7
RTECS #:AS4375000
Fraction by Wt: 5-8%
OSHA PEL:10 PPM (MFR)
ACGIH TLV:2 PPM, S
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:METHACRYLIC ACID, 2-HYDROXYETHYL ESTER; (HYDROXYALKYL
METHACYLATE)
CAS:868-77-9
RTECS #:OZ4725000
Fraction by Wt: 3-5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PHOTOINTIATOR
CAS:987-19-3
Fraction by Wt: 3-5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:VOLATILE ORGANIC COMPOUNDS (EPA METHOD 24): 48.9%.
RTECS #:9999999VO
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(ORAL) >5000 MG/KG.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE DERMATITIS ON CONTACT IN
SENSITIVE INDIVIDUALS. INHALATION OF VAPORS ESPECIALLY THOSE OF
ACRYLIC ACID MAY CAUSE NOSE AND THROAT IRRITATION. PROLONGED
CONTACT MAY CAUSE SENSITIZATION.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/LG AMTS OF WATER FOR AT LST 15 MINS. CONT MD.
OBTAIN MED ATTN. SKIN:REMOVE CONTAM CLTHG. FLUSH AREAS OF CONT
W/WATER. WASH AREAS OF CONT W/WATERLESS HAND CLEANER/SOAP & WATER.
INHAL:REMOV E TO FRESH AIR. IF BRTHG IS DFCLT ADMINOXYG. IF BRTHG
HAS STOPPED ADMIN ARTF RESP. IF SYMPS PERSIST OBTAIN MED ATTN.
INGEST:DO NOT INDUCE VOMIT. KEEP INDIVIDUAL CALM. OBTAIN MED ATTN.
INGEST:(SUPDAT)
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:>200F,>93C
Lower Limits:2%
Upper Limits:8%
Extinguishing Media:CARBON DIOXIDE, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:SOAK UP WITH INERT ABSORBENT. STORE IN A
SEALED PARTIALLY FILLED CONTAINER UNTIL DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE <95F TO PRESERVE SHELF LIFE.
AVOID UNNECESSARY EXPOSURE TO LIGHT AND HEAT TO PREVENT PREMATURE
CURING. AVOID PROLONGED SKIN CONTACT.
Other Precautions:KEEP AWAY FROM EYES. AVOID PROLONGED BREATHING OF
VAPORS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN . RESPIRATORS ARE NOT REQUIRED UNDER NORMAL
CONDITIONS OF USE.
Ventilation:GENERAL VENTILATION SHOULD BE ADEQUATE.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRST AID PROCEDURE: DO NOT INDUCE VOMITING. KEEP INDIVIDUAL CALM.
OBTAIN MEDICAL ATTENTION. NOTES TO MD: SENSITIVE INDIVIDUALS SHOULD
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>300F,>149C
Vapor Pres:<5 @ 20C
Spec Gravity:1.1
Solubility in Water:SLIGHTLY SOLUBLE
Appearance and Odor:CLEAR AMBER LIQUID W/SHARP ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:TO AVOID PREMATURE CURING, KEEP PACKAGE &
CONTENTS AWAY FROM SUNLIGHT & OTHER HEAT SOURCES & STORE BELOW 95F.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
IRRITATING ORGANIC VAPS & OXIDES OF NITROGEN MAY BE PRODUCED FROM
THERMAL DECOMP.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL OF IN ACCORDANCE WITH LOCAL, STATE &
FEDERAL RULES AND REGULATIONS. DISPOSAL METHODS MAY INCLUDE
INCINERATION OR LANDFILL. DESTROY SYRINGE NEEDLES BEFORE
DISCARDING.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MICROGRIT GB
CAGE:62596
CAGE:62596
============= Composition/Information on Ingredients =============
Ingred Name:ALPHA-ALUMINA (ALUMINUM OXIDE) (EPA LISTS ONLY FIBROUS
FORMS) (SARA III)
CAS:1344-28-1
RTECS #:BD1200000
Fraction by Wt: 95-99%
Other REC Limits:N/K
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
===================== Hazards Identification =====================
LD50 LC50 Mixture:N/K
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PULMONARY EFFECTS OF INERT DUST.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES/SKIN/INGESTION:N/K .INHALATION:PULMONARY
EFFECTS OF INERT DUST.LOW HEALTH RISK BY INHALATION.TREAT AS A
NUISANCE DUST AS SPECIFIED BY THE AMERICAN CONFERENCE OF
GOVERNMENTAL INDUSTRIAL HYGIENISTS (ACGIH).
Medical Cond Aggravated by Exposure:N/K
======================= First Aid Measures =======================
First Aid:EYES:FLUSH WITH LARGE AMOUNTS OF WATER FOR AT LEAST 15
MINUTES .SKIN:N/K .INGESTION:CALL MD IMMEDIATELY .INHALATION:REMOVE
TO FRESH AIR.SUPPORT BREATHING (GIVE O*2/ARTIFICIAL RE SPIRATION) .
===================== Fire Fighting Measures =====================
Extinguishing Media:PRODUCT IS NONFLAMMABLE.
Fire Fighting Procedures:PRODUCT IS NONFLAMMABLE;DOES NOT SUPPORT
COMBUSTION;NOT AN EXPLOSION HAZARD.
Unusual Fire/Explosion Hazard:PRODUCT IS NONFLAMMABLE;DOES NOT SUPPORT
COMBUSTION;NOT AN EXPLOSION HAZARD.
================== Accidental Release Measures ==================
Spill Release Procedures:AVOID DUSTING DURING CLEAN-UP.
Neutralizing Agent:N/K
======================Handling and Storage ======================
Handling and Storage Precautions:USE WITH ADEQUATE VENTILATION AS WITH
NUISANCE DUST.DO NOT EXCEED TLV LIMITS.
Other Precautions:N/K
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AN APPROVED RESPIRATOR IF TLV IS EXCEEDED.
Ventilation:LOCAL EXHAUST RECOMMENDED.
Work Hygienic Practices:N/K
Supplemental Safety and Health
INSOLUBLE IN ORGANIC SOLVENTS.ROUTES OF ENTRY:INHALATION/SKIN/INGESTION
.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:N/K
Decomp Temp:Decomp Text:N/K
Spec Gravity:3.8-4.0,WATER=1
Solubility in Water:INSOLUBLE
Appearance and Odor:CRYSTALLINE WHITE POWDER,NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:N/K
Hazardous Decomposition Products:NONE
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH
FEDERAL,STATE AND LOCAL REGULATIONS .WASTE MAY BE CONSIDERED AS
INERT MATERIAL;SUITABLE FOR LANDFILL.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TEFLON FLUOROCARBON RESIN PTFE FINE POWDERS
Preparer's Name:W H MARTIN
CAGE:18873
CAGE:18873
============= Composition/Information on Ingredients =============
Ingred Name:ETHYLENE, TETRAFLUORO-, POLYMER (POLYTETRAFLUOROETHYLENE)
CAS:116-14-3
RTECS #:KX4025000
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:(ACUTE) INGEST: NOT TOXIC. SKIN: NOT
TOXIC. EYE: MECHANICAL IRRITATION. INHAL: WHEN THERMALLY DECOMPOSED
BY HEATING >280C, OR BY SMOKING TOBACCO OR CIGARETTES CONTAM
W/POLYMER DUST, MAY CAUSE POLYMER FUME FEVER. SYMP ARE FLU-LIKE,
W/CHILLS& FEVER, WHICH MAY NOT OCCUR UNTIL SEV HRS AFTER EXPOS (SEE
EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: AND PASS OFF WITHIN 36-48 HRS, EVEN
IN ABSENCE OF TREATMENT. DUPONT RECOMMENDS TREATING POLYMER DUST AS
A NUISANCE PARTICULATE, AND HAS ESTABLISHED AN AEL OF 10 MG/M3
TOTAL DUST, THE SAME AS THE TLV FOR OTHER NUISANCE PARTICULATES.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:IF EXPOSED TO FUMES FROM OVERHEATING OR COMBUSTION, MOVE TO
FRESH AIR. CONSULT PHYSICIAN IF SYMP PERSIST. FLUSH EYES WITH
PLENTY OF WATER FOR AT LEAST 15 MIN. CONSULT PHYSICIAN IF SYMP
PERSIST. IF MOL TEN POLYMER CONT SKIN, COOL RAPIDLY WITH COLD
WATER. DO NOT ATTEMPT TO PEEL POLYMER FROM SKIN. OBTAIN MEDICAL
ATTN FOR THERMAL BURN. INGEST: CALL MD IMMED .
===================== Fire Fighting Measures =====================
Flash Point Method:OC
Flash Point:DOES NOT FLASH
Extinguishing Media:WATER, CO*2, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
TO PROTECT FROM HF FUMES WHICH REACT W/WATER TO FORM HYDROFLUORIC
ACID. DOES NOT BURN W/O AN (SEE SUPP DATA)
Unusual Fire/Explosion Hazard:TOXIC FLUORINE COMPOUNDS EVOLVED IN FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP TO AVOID SLIPPING HAZARD.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTAM. KEEP CONTAINERS CLOSED.
BEFORE USING, READ TEFLON "SAFETY IN HANDLING AND USE", BULLETIN
E-35824-1.
Other Precautions:AVOID CONTAMINATION OF CIGARETTES OR TOBACCO WITH
POLYMER DUST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR WHEN
TEMPERATURE EXCEEDS 280C IF VENTILATION IS INADEQUATE TO MAINTAIN
HF CONC BELOW THE PERMISSIBLE EXPOSURE LIMIT.
Ventilation:USE LOCAL EXHAUST TO COMPLETELY REMOVE VAPORS AND FUMES
LIBERATED DURING HOT PROCESSING FROM THE WORK AREA.
Other Protective Equipment:LONG SLEEVE SHIRT.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
WHEN HANDLING REFUSE FROM A FIRE INVOLVING TEFLON. HAZ DECOMP
PRODS: EVOLVE TOXIC GASEOUS MATLS SUCH AS HF & PERFLUOROOLEFINS. TH
E OSHA PEL FOR HF IS 3 PPM. PARTICULATEMATTER EVOLVED FROM
OVERHEATING MAY CAUSE POLYMER FUME FEVER (SEE HLTH HAZ).
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:648F,342C
Spec Gravity:2.1-2.3
Solubility in Water:INSOLUBLE
Appearance and Odor:WHITE POWDER, NO ODOR.
================= Stability and Reactivity Data =================
MOLTEN ALKALI METALS, INTERHALOGEN COMPOUNDS.
Stability Condition to Avoid:TEFLON WILL BURN IN A ATMOSPHERE OF 95%
OXYGEN WHEN AN IGNITION SOURCE IS PRESENT.
Hazardous Decomposition Products:HF, CARBONYL FLUORIDE, CO & LOW
MOLECULAR WEIGHT FLUOROCARBONS. >280C TEFLON PTFE FINE POWDER
RESINS CAN (SEE SUPP DATA)
==================== Disposal Considerations ====================
Waste Disposal Methods:LANDFILL PREFERRED; DISPOSAL METHODS MUST
CONFORM TO FEDERAL, STATE, AND LOCAL REGULATIONS. WITH
INCINERATION, ACIDIC GASEOUS PRODUCT MUST BE REMOVED BY ALKALINE
SCRUBBING.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:VERY BEST SPRAY
CAGE:FO999
CAGE:FO999
============= Composition/Information on Ingredients =============
Ingred Name:FRAGRANCE
Fraction by Wt: 1-10%
Ingred Name:TRITON X-100, OCTYLPHENOXYPOLYETHOXYETHANOL
CAS:9036-19-5
RTECS #:RI0525000
Fraction by Wt: 1-10%
Ingred Name:ISOPROPANOL (ISOPROPYL ALCOHOL), 2-PROPANOL, DIMETHYL
CARBINOL
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 15-98%
Other REC Limits:400 PPM
OSHA PEL:400 PPM
ACGIH TLV:400 PPM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION. SKIN: IRRITATION &
DERMATITIS. INHALATION: NOSE, THROAT IRRITATION, NAUSEA, HEADACHE &
MILD NARCOSIS. INGESTION: MOUTH/THROAT BURNS, NAUSEA, VOMITING,
BLEEDING, CENTRAL NERVOUS SYSTE M DEPRESSION, HEMOYSIS, LUNG
DAMAGE, INJURY & FATAL.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES: IRRITATION. SKIN: IRRITATION &
DERMATITIS. INHALATION: NOSE, THROAT IRRITATION, NAUSEA, HEADACHE &
MILD NARCOSIS. INGESTION: MOUTH/THROAT BURNS, NAUSEA, VOMITING,
BLEEDING, CENTRAL NERVOUS SYSTE M DEPRESSION, HEMOYSIS, LUNG
DAMAGE, INJURY & FATAL.
Medical Cond Aggravated by Exposure:DERMATITIS
======================= First Aid Measures =======================
First Aid:EYES/SKIN: FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MINS.
INHALATION: REMOVE TO FRESH AIR. GIVE CPR OR OXYGEN IF NEEDED.
INGESTION: DRINK MILK/WATER. INDUCE VOMITING BY STICKING FINGER TO
BACK OF THROA T. KEEP HEAD BELOW WAIST. NEVER GIVE ANYTHING BY
MOUTH TO AN UNCONSCIOUS PERSON OR IS HAVING CONVULSIONS. OBTAIN
MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point: 107F
Lower Limits: 2%
Upper Limits: 12%
Extinguishing Media:CO2, DRY CHEMICAL & ALCOHOL FOAM
Fire Fighting Procedures:COOL FIRE-EXPOSED CONTAINERS W/WATERSPRAY.
FINE WATER MIST TO SMOTHER FIRE/DISPERSE VAPORS. WEAR SCBA/FULL
PROTECTIVE CLOTHING. DON'T USE SOLID STREAM OF WATER.
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR & MAY TRAVEL
A DISTANCE TO IGNITION SOURCES & FLASHBACK.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE IGNITION SOURCES. VENTILATE/EVACUATE
AREA. REMOVE LEAKING CONTAINER TO SAFE PLACE. ABSORB SMALL SPILLS &
COLLECT LIQUID OR ABSORB W/VERMILCULITE OR SAND. PLACE WASTE OR
ABSORBENT INTO CLOSED CONTAINER USING NON-SPARKING TOOLS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN CLOSED CONTAINERS IN A COOL,
DRY, WELL-VENTILATED AREA. ELMINATE IGNITION SOURCES. STORAGE AREAS
SHOULD HAVE AN EXPLOSION-PROOF DESIGN.
Other Precautions:PROTECT CONTAINERS FROM PHYSICAL DAMAGE. GROUND &
BOND METAL CONTAINERS & EQUIPMENT WHEN TRANSFERRING OR POURING
LIQUID. USE NON-SPARKING TOOLS. DON'T WEAR CONACT LENSES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED RESPIRATOR
Ventilation:LOCAL EXHAUST/GENERAL EXPLOSION PROOF
Other Protective Equipment:FULL PROTECTIVE CLOTHING, EYE WASH/SAFETY
SHOWER STATION
Work Hygienic Practices:DON'T SMOKE. REMOVE/LAUNDER CONTAMINATED
CLOTHING BEFORE REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text: 210F
Vapor Density:N//K
Appearance and Odor:CLEAR LIQUID, COLOR VARIES W/FRAGRANCE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME & OTHER IGNITION
SOURCES
Hazardous Decomposition Products:CO
==================== Disposal Considerations ====================
Waste Disposal Methods:BURN WASTE LIQUID IN APPROVED INCINERATOR OR
DISPOSE OF VIA LICENSED WASTE DISPOSAL COMPANY. DISPOSE W/FEDERAL,
STATE & LOCAL REGULATIONS. DON'T FLUSH TO SEWER OR STREAM.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:244 CROWN LATEX ARCHITECTURAL COATING
CAGE:85207
CAGE:72556
CAGE:85207
============= Composition/Information on Ingredients =============
Ingred Name:VINYL ACETATE
CAS:108-05-4
RTECS #:AK0875000
Fraction by Wt: <0.1%
Other REC Limits:10 PPM
ACGIH TLV:35 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:2-(2-BUTOXYETHYOXY)-ETHANOL, DIETHYLENE GLYCOL MONOBUTYL
ETHER (BUTYL CARBITOL) *97-2*
CAS:112-34-5
RTECS #:KJ9100000
Fraction by Wt: <5%
Ingred Name:VOLATILE ORGANIC CONTENT: <200 G/L
RTECS #:9999999VO
Ingred Name:TITANIUM DIOXIDE, TITANIUM OXIDE (SUSPECTED ANIMAL
CARCINOGEN, IARC GROUP 3)*97-2*
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 15%
OSHA PEL:15 MG/CUM
ACGIH TLV:10 MG/CUM (DUST)
Ingred Name:CALCIUM CARBONATE, DOMOLITE, LIMESTONE, WHITING *97-2*
CAS:1317-65-3
RTECS #:EV9580000
Fraction by Wt: 5%
Other REC Limits:5 MG/M3 RESP DUST
OSHA PEL:15 MG/M3
ACGIH TLV:10 MG/CUM TOTAL DUST
Ingred Name:CRYSTALLINE-QUARTZ SILICA, SILICA DUST (SUSPECTED HUMAN
CARCINOGEN BY IARC-GROUP 2A; SUSPECTED CARCINOGEN NTP) *97-2*
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: <5%
Other REC Limits:0.05 MG/CUM (NIOSH)
OSHA PEL:10 MG/CUM %RESP SIO2
ACGIH TLV:0.1 MG/CUM RESP DUST
Ingred Name:SILICA CRYSTALLINE, SILICA (CRISTOBALITE) (SUSPECTED HUMAN
CARCINOGEN BY IARC, SUSP CARC BY NTP; IARC GROUP 2A) *97-2*
CAS:14464-46-1
RTECS #:VV7325000
Fraction by Wt: <5%
Other REC Limits:0.05 MG/CUM NIOSH
ACGIH TLV:0.05 MG/CUM
Ingred Name:ETHYLENE GLYCOL *97-2*
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: <5%
Other REC Limits:10 MG/CUM
OSHA PEL:50 PPM
ACGIH TLV:C 127 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:ETHYLENE OXIDE (SUSP HUMAN CARCINOGEN BY ACGIH, IARC, SUSP
CARC BY NTP; OSHA CANCER HAZARD; IARC - GROUP 1) *97-2*
CAS:75-21-8
RTECS #:KX2450000
Fraction by Wt: <0.1%
ACGIH TLV:1.8 MG/CUM (A2)
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:FORMALDEHYDE, FORMALIN (SUSPECTED HUMAN CARCINOGEN BY IARC;
ACGIH; SUSPECTED CARCINOGEN BY NTP; IARC - GROUP 2A) *97-2*
CAS:50-00-0
RTECS #:LP8925000
Fraction by Wt: <0.1%
ACGIH TLV:0.37 MG/CUM IC (2A)
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:1,2-PROPANEDIOL (PROPYLENE GLYCOL)
CAS:57-55-6
RTECS #:TY2000000
Fraction by Wt: <5%
Ingred Name:AMORPHOUS SILICA GEL, SILICON DIOXIDE *97-2*
CAS:7631-86-9
Fraction by Wt: 10%
Ingred Name:PROPANOIC ACID, 2-METHYL, MONOESTER
W/2,2,4-TRIMETHYL-1,3-PENTANEDIOL, TEXANOL(ESTER ALCOHOL)
CAS:25265-77-4
RTECS #:UF6000000
Fraction by Wt: <5%
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT): 9500 MG/KG (SEE SUPP)
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:PRIMARY IRRITANT. HAZARDS OF
INDIVIDUAL INGREDIENTS; EYE: IRIDOCYCLITIS, BURNS, POSSIBLE
PERMANENT DAMAGE. SKIN: BURNS, DERMATITIS. INHALATION: LUNG INJURY,
CNS DEPRESSION, SILICOSIS, PNEUMONIA, EDEMA . INGESTION: CNS
EFFECTS, GI TRACT IRRITATION. ADVERSE REPRODUCTIVE EFFECTS &
CHROMOSOME DAMAGE. (SEE SUPP)
Explanation of Carcinogenicity:SEE INGREDIENTS
Effects of Overexposure:IRRITATION, ECZEMA-LIKE CONDITION, DEFATTING,
HEADACHE, NAUSEA, VOMITING, DIFFICULTY BREATHING, DIZZINESS, COUGH,
CYANOSIS, DROWSINESS, PAIN, DIARRHEA, UNCONSCIOUSNESS
Medical Cond Aggravated by Exposure:LUNG DISEASE, SKIN & RESPIRATORY
CONDITIONS.
======================= First Aid Measures =======================
First Aid:INGESTION: DRINK 2 GLASSES OF WATER & INDUCE VOMITING BY
PLACING FINGER AT BACK OF THROAT. NEVER GIVE ANYTHING BY MOUTH TO
AN UNCONSCIOUS PERSON. INHALATION: REMOVE TO FRESH AIR. RESTORE
BREATHING. EY ES: FLUSH W/COOL WATER FOR 15 MINS. SKIN: WASH
THOROUGHLY W/SOAP & WATER. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:>200F
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:SOAK UP & REMOVE W/INERT ABSORBENT MATERIAL.
PROVIDE ADEQUATE VENTILATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE APPROVED MECHANICAL RESPIRATOR/MASK TO AVOID
BREATHING SPRAY MISTS.
Ventilation:PROVIDE SUFFICIENT VENTILATION IN VOLUME & PATTERN TO KEEP
BELOW TLV.
Other Protective Equipment:PROTECTIVE OVERALLS
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. DISCARD CONTAMINATED SHOES.
Supplemental Safety and Health
THIS IS A LATEX PAINT. PRIMARY HEALTH HAZARD IS POSSIBLE IRRITATION TO
EYES & SKIN. HEALTH HAZARDS ARE FOR EACH INGREDIENT. LD50
INFORMATION IS FOR TITANIUM DIOXIDE.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F
Vapor Density:<1
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:65
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:EXTREME HEAT
Hazardous Decomposition Products:CO, CO2, NITROGEN OXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS. DON'T INCINERATE IN CLOSED CONTAINERS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:HYDROCHLORIC ACID 2%, 250
CAGE:24774
CAGE:24774
============= Composition/Information on Ingredients =============
Ingred Name:NON HAZARDOUS INGREDIENTS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: SLIGHTLY IRRITATING TO THE
SKIN. MODERATELY IRRITATING TO THE EYES. VAPORS, GASES, MISTS
AND/OR AEROSOLS MAY CAUSE IRRITATION TO UPPER RESPIRATORY TRACT.
CHRONIC: PROLONGED OR REPEATED CONTACT MAY CAUSE PRIMARY IRRITANT
DERMATITIS.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:INHALATION MAY CAUSE IRRITATION OF RESPIRATORY
TRACT; SKIN CONTACT MAY CAUSE ITCHING AND/OR REDNESS.
Medical Cond Aggravated by Exposure:NONE KNOWN
======================= First Aid Measures =======================
First Aid:SKIN: REMOVE CONTAMD CLTHG. WASH EXPOSED AREA W/LG QTYS OF
SOAP SOLN OR WATER FOR AT LST 15 MIN. EYE: IMMED FLUSH W/WATER FOR
AT LST 15 MIN. IMMED CONT MD FOR ADDITIONAL TREATMENT. INHAL:
REMOVE FROM CONTAMD AREA TO FRESH AIR. APPLY APPROPFIRST AID
TREATMENT AS NECESSARY. INGEST: GEN - DO NOT INDUCE VOMIT. IMMED
CONT MD. DILUTE CONTENTS OF STOMACH USING 3-4 GLASSES MILK OR
WATER.
===================== Fire Fighting Measures =====================
Extinguishing Media:DRY CHEMICAL, CARBON DIOXIDE, FOAM OR WATER.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:GEN:VENT AREA, USE SPECIFIED PROT
EQUIP.CONTAIN & ABSORB ON ABSORB MATL.PLACE IN WASTE DISP
CNTNR.WASTE CHARACT OF ABSORBED MATL/ANY CONTAMD SOIL, SHLD BE
DETERMD I/A/W RCRA REGS.SPECIFIC:FLUSH AREA W /WATER.WET AREA MAY
BE SLIPPERY. SPREADSAND/GRIT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED WHEN NOT IN USE.
DO NOT FREEZE. IF FROZEN, THAW AND MIX COMPLETELY PRIOR TO USE.
ACIDIC. DO NOT MIX WITH ALKALINE MATERIAL.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF VENTILATION IS INADEQUATE OR SIGNIFICANT
REAGENT EXPOSURE IS LIKELY, USE NIOSH/MSHA APPROVED RESPIRATOR WITH
ACID GASES CARTRIDGES AND DUST/MIST PREFILTERS.
Ventilation:ADEQUATE VENTILATION.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
AS NECESSARY.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Spec Gravity:1
pH:AS IS
Solubility in Water:100%
Appearance and Odor:COLORLESS; PUNGENT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:(DESTRUCTIVE FIRES) YIELDS ELEMENTAL
OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF I/A/W FED, STATE AND LOCAL
REGULATIONS . GEN: WATER CONTAMD W/REAGENT MAY BE SENT TO A
SANITARY SEWER, I/A/W ANY LOCAL AGREEMENT, A TREATMENT
FACILITY/DISCHARGED UNDER A NPDES PERMIT. REAGENT (AS IS):
INCIN/BURY IN APPROVED LANDFILL.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:P1104;GLYCERINE
CAGE:OAN91
CAGE:OAN91
============= Composition/Information on Ingredients =============
Ingred Name:GLYCERIN (GLYCEROL)
CAS:56-81-5
RTECS #:MA8050000
Fraction by Wt: 96-99.5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:15 MG/M3 (MIST)
ACGIH TLV:10 MG/M3 (MIST);9495
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: BALANCE
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT) IS 12.6 G/KG
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES:MAY CAUSE IRRITATION.SKIN:MAY
CAUSE SLIGHT IRRITATION REGARDLESS OF THE EXTENT OF
EXPOSURE.INGEST:LARGE AMOUNTS MAY CAUSE GI TRACT
IRRITATION.INHAL:UNLIKELY ROUTE OF EXPOSURE.
Explanation of Carcinogenicity:THERE ARE NO INGREDIENTS ABOVE 0.1%
WHICH ARE IDENTIFIED AS CARCINOGENS BY NTP,IARC OR OSHA.
Effects of Overexposure:INGEST:NAUSEA,VOMITING.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:SKIN:REMOVE CONTAMINATED CLOTHING;WASH WITH SOAP AND
WATER.GET MEDICAL ATTENTION FOR IRRITATION.EYES:FLUSH WITH WATER
FOR 15 MINUTES.GET IMMEDIATE MEDICAL ATTENTION.INHAL:REMOVE TO
FRESH AIR.GIVE OXYG EN OR ARTIFICIAL RESPIRATION IF
NEEDED.INGEST:DO NOT INDUCE VOMITING.GET PROMPT QUALIFIED MEDICAL
ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:320F,160C
Extinguishing Media:WATER SPRAY,DRY CHEMICAL,CARBON DIOXIDE,FOAM.
Fire Fighting Procedures:USE A SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE EQUIPMENT.COOL FIRE EXPOSED CONTAINERS WITH WATER
FOG.
Unusual Fire/Explosion Hazard:MANUFACTURER STATES NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER RESPIRATORY AND PROTECTIVE
EQUIPMENT.SOAK UP WITH NON-COMBUSTIBLE INERT
ADSORBANT(EG.CLAY);PLACE COLLECTED MATERIAL IN AN APPROPRIATE
CONTAINER FOR DISPOSAL;CLEAN SPILL AREA TO REMOVE SLIPP
ERINESS.AVOID CONTAMINATING THE ENVIRONMENT.
Neutralizing Agent:NOT APPLICABLE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL,DRY,WELL-VENTILATED
PLACE.KEEP CONTAINER CLOSED WHEN NOT IN USE.KEEP AWAY FROM
INCOMPATIBLE MATERIALS.
Other Precautions:THIS ITEM IS INTENED FOR FOOD USE;AVOID
CONTAMINATION.EMPTY CONTAINERS MAY CONTAIN HAZARDOUS
RESIDUE;DISPOSE OF PROPERLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED;USE WITH ADEQUATE VENTILATION.
Ventilation:USE GENERAL DILUTION VENTILATION.
Other Protective Equipment:LONG SLEEVED SHIRT,SAFETY SHOES.PROVIDE A
LOCAL EYE WASH STATION AND SAFETY SHOWER.
Work Hygienic Practices:USE REASONABLE CARE IN HANDLING THIS
PRODUCT.WASH HANDS AFTER USE AND BEFORE EATING.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:550F,288C
Vapor Pres:NIL
Spec Gravity:1.26
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS LQUID,BLAND ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:MAY LIBERATE ACROLEIN.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL,STATE AND
LOCAL REGULATIONS.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:PBW 20
CAGE:77513
CAGE:77513
============= Composition/Information on Ingredients =============
Ingred Name:DIESEL FUEL
Fraction by Wt: 80%
Other REC Limits:NONE SPECIFIED
ACGIH TLV:200 PPM
===================== Hazards Identification =====================
Health Hazards Acute and Chronic:INHALATION:CAUSES SEVERE LUNG
IRRITATION. INGESTION: CAUSES NAUSEA, VOMITING & CRAMPING. SIGNS OF
KIDNEY & LIVER DAMAGE MAY BE DELAYED.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:LOCAL IRRITATION. DROWSINESS, NAUSEA, VOMITING,
CRAMPING & DEPRESSION OF CENTRAL NERVOUS SYSTEM RANGING FROM MILD
HEADACHE TO ANETHYSIA, COMA & POSSIBLE DEATH.
Medical Cond Aggravated by Exposure:ASPIRATION CAUSES SEVERE LUNG
IRRITATION WITH COUGHING, GAGGING, DYSPNEA, SUBSTERNAL DISTRESS &
RAPIDLY DEVELOPING PULMONARY EDEMA.
======================= First Aid Measures =======================
First Aid:SKIN CONTACT:WASH WITH SOAP & WATER. EYES:FLUSH WITH WATER,
OBTAIN MEDICAL ATTENTION. INGESTION:DO NOT INDUCE VOMITING.
ASPIRATION:ENFORCE BED REST, ADMINSTER OXYGEN, SEEK MEDICAL
ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:142F,61C
Extinguishing Media:CARBON DIOXIDE, FOAM OR DRY CHEMICAL
Fire Fighting Procedures:AS FOR PETROLEUM FIRE
Unusual Fire/Explosion Hazard:WATER MAY BE INEFFECTIVE ON FIRE. USE
WATER TO COOL CONTAINER.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. WIPE UP SPILLAGE. CONTAIN AS
NECESSARY. TRANSFER TO METAL CONTAINERS.
======================Handling and Storage ======================
Handling and Storage Precautions:TRANSPORT & STORE IN CLOSED CONTAINERS
AT TEMPERATURES BETWEEN 32F & 120F
============= Exposure Controls/Personal Protection =============
Ventilation:MECHANICAL (GENERAL)
Work Hygienic Practices:IF SPILLED ON CLOTHING REMOVE & WASH CLOTHING.
Supplemental Safety and Health
OTHER COMPONENTS NOT DEFINED AS HAZARDOUS BY THE U.S. DEPT. OF LABOR.
================== Physical/Chemical Properties ==================
HCC:V4
Boiling Pt:B.P. Text:355F,179C
Melt/Freeze Pt:M.P/F.P Text:5
Vapor Pres:10MM
Vapor Density:1
Spec Gravity:0.87
Evaporation Rate & Reference:1 (BUTYL ACETATE=1)
Solubility in Water:MODERATE
Appearance and Odor:CLEAR AMBER LIQUID, SOLVENT ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:AS FOR PETROLEUM SOLVENTS. MUST BE IN COMPLIANCE
WITH LOCAL, STATE & FEDERAL REGULATIONS. DO NOT DUMP INTO SEWERS,
ON THE GROUND OR ANY BODY OF WATER.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SILVER METAL AND SOLUBLE SILVER COMPOUNDS (SILVER NITRATE)
Kit Part:Y
CAGE:23667
CAGE:23667
============= Composition/Information on Ingredients =============
Ingred Name:SILVER NITRATE (SARA 313) (CERCLA)
CAS:7761-88-8
RTECS #:VW4725000
Fraction by Wt: 100%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.01 MG(AG)/M3
ACGIH TLV:0.01 MG(AG)/M3; 9495
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: MAY CAUSE IRRITATION, ULCERS
AND DISCOLORATION OF SKIN. IF INGESTED, MAY CAUSE ABDOMINAL PAIN
AND GASTROENTERITIS. CHRONIC: PROLONGED OR REPEATED EXPSOURE MAY
CAUSE ARGYRIA (DISCOLORATION/PIGME NTATION).
Explanation of Carcinogenicity:NO INGREDIENT OF A CONCENTRATION OF 0.1%
OR GREATER IS LISTED AS A CARCINOGEN OR SUSPECTED CARCINOGEN.
Effects of Overexposure:IRRITATION, ULCERS, DISCOLORATION OF SKIN;
ABDOMINAL PAIN, GASTROENTERITIS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES-FLUSH WITH LOTS OF WATER FOR 15 MINUTES, LIFT LIDS. GET
MEDICAL ATTENTION IMMEDIATELY. SKIN-REMOVE CONTAMINATED CLOTHES.
FLUSH WITH WATER. GET MEDICAL ATTENTION IF SYMPTOMS DEVELOP.
INHALED-REMOV E TO FRESH AIR. IF BREATHING STOPPED, GIVE ARTIFICIAL
RESPIRATION. GET MEDICAL ATTENTION. INGESTED-DO NOT INDUCE
VOMITING! IF CONSCIOUS, GIVE LOTS OF WATER. GET IMMEIDATE MEDICAL
ATTENTION.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE MEDIA APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE GEAR. COOL FIRE EXPOSED CONTAINERS WITH WATER.
Unusual Fire/Explosion Hazard:SILVER NITRATE IS A STRONG OXIDING
MATERIAL CAPABLE OF INCREASING THE FLAMMABILITY OF COMBUSTIBLE,
ORGANIC OR OTHER READILY OXIDIZABLE MATERIALS.
================== Accidental Release Measures ==================
Spill Release Procedures:ISOLATE & DENY ENTRY. WEAR PROPER PROTECTIVE
CLOTHING/EQUIPMENT. VENTILATE AREA OF SPILL OR LEAK. ABSORB ON
INERT MATERIAL AND PLACE IN A CONTAINER FOR LATER DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY, WELL-VENTILATED
PLACE AWAY FROM HEAT AND INCOMPATIBLE MATERIALS.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF ENGINEERING CONTROLS FAIL OR NON-ROUTINE USE
OR AN EMERGENCY OCCURS; WEAR AN MSHA/NIOSH APPROVED RESPIRATOR OR
AN AIR-SUPPLIED RESPIRATOR OR SCBA, AS REQUIRED. USE IN ACCORDANCE
WITH 29 CFR 1910.13 4 AND MANUFACTURER'S RECOMMENDATIONS.
Ventilation:USE ADEQUATE MECHANICAL VENTILATION OR LOCAL EXHAUST TO
MAINTAIN EXPOSURE BELOW TLV(S).
Other Protective Equipment:EYE WASH STATION & SAFETY SHOWER. RUBBER
BOOTS, APRON.
Work Hygienic Practices:WASH HANDS AFTER HANDLING AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health
KEY1=D1. MSDS IF PART D OF 4 PART KIT. HCC IS BASED ON PNI B. NOTE:
DISPOSAL DATA- EPA/RCRA WASTE NUMBER D011 MAY APPLY TO
UNUSED/UNCONTAMINATED PRODUCT (PER DEMIL INTRUCTIONS).
================== Physical/Chemical Properties ==================
HCC:D1
Boiling Pt:B.P. Text:772F,411C
Melt/Freeze Pt:M.P/F.P Text:408F,209C
Decomp Temp:Decomp Text:772F,411C
Vapor Pres:NEGLIGIBLE
Spec Gravity:4.4
Solubility in Water:APPRECIABLE
Appearance and Odor:COLORLESS TO GREY SOLID; ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACETYLENE, AMMONIA, STRONG HYDROGEN PEROXIDE; MAY ATTACK SOME FORMS OF
PLASTICS, RUBBER, COATINGS.
Stability Condition to Avoid:HEAT; CONTACT WITH INCOMPATIBLE MATERIALS.
Hazardous Decomposition Products:TOXIC GASES AND VAPORS (EG OXIDES OF
NITROGEN) MAY BE RELEASED WHEN DECOMPOSED.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:SILVER METAL AND SOLUBLE SILVER COMPOUNDS MAY BE
DISPOSED OF IN SEALED CONTAINERS IN A SECURED SANITARY LANDFILL.
DEMILITARIZATION WILL BE PER DRMS-H 4160.3 VOL 1 CHAPTER XVIII-3,
SEPTEMBER 1990.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ENAMEL, ALKYD, GLOSS, LO VOC CT OLIVE DRAB 14064, ID 774412
Preparer's Name:W A ELLISON
CAGE:61196
CAGE:61196
============= Composition/Information on Ingredients =============
Ingred Name:N-BUTYL ACETATE (SOLVENT) (VAPOR PRESSURE 10 MM HG @ 20C)
(LFL 1.7; UFL 7.6)
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: 10%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:150 PPM;STEL 200 PPM
ACGIH TLV:150 PPM;STEL 200 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:XYLENE (SOLVENT) (SARA III) (VAPOR PRESSURE 5 MM HG @ 20C)
(LFL 1.0; UFL 7.0)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 20%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM;STEL 150 PPM
ACGIH TLV:100 PPM;STEL 150 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:TITANIUM DIOXIDE (PIGMENT)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: <5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:SILICA, CRYSTALLINE (PIGMENT)
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.1000 MG/M3
ACGIH TLV:0.1000 MG/M3
Ingred Name:SILICA, CRYSTALLINE - TRIPOLI
CAS:1317-95-9
RTECS #:VV7336000
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.1000 MG/M3
ACGIH TLV:0.1000 MG/M3
Ingred Name:STODDARD SOLVENT (SOLVENT) (LFL 0.8)
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: <5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM; 525 MG/M3
ACGIH TLV:100 PPM; 525 MG/M3
Ingred Name:METHYL ETHYL KETONE (SOLVENT) (SARA III) (VAPOR PRESSURE 70
MM HG @ 20C) (LFL 2.0; UFL 10.0)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:200 PPM;STEL 300 PPM
ACGIH TLV:200 PPM;STEL 300 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:VOC: 3.02 LB/GAL LESS WATER & NEGLIGIBLY PHOTOCHEMICALLY
REACTIVE MATERIALS; 362 G/L LESS WATER; CALCULATED
RTECS #:9999999VO
Other REC Limits:NONE RECOMMENDED
Ingred Name:VOC: 3.02 LB/GAL LESS WATER & NEGLIGIBLY PHOTOCHEMICALLY
REACTIVE MATERIALS; 362 G/L LESS WATER; CALCULATED
RTECS #:9999999VO
Fraction by Wt: NA
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NA
ACGIH TLV:NA
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:UNKNOWN IARC:YES
Health Hazards Acute and Chronic:INGEST: GASTROINTESTINAL IRRIT,
NAUSEA, VOMITING. ASPIRATION INTO LUNG MAY CAUSE CHEM PNEUMONITIS
(CAN BE FATAL). INHAL: NOSE OR THROAT IRRIT. ACUTE CENTRAL NERVOUS
SYSTEM DEPRESSION (HEADACHES, DIZZI NESS, NAUSEA, CONFUSION). EYE:
SEVERE IRRIT. SKIN: ABSORBED THROUGH SKIN IN HARMFUL AMTS.
DEFATTING & SKIN IRRIT.
Explanation of Carcinogenicity:IARC CONSIDERS CRYSTALLINE SILICA TO
HAVE LIMITED EVIDENCE OF CARCINOGENICITY IN HUMANS & SUFFICIENT IN
ANIMALS.
Effects of Overexposure:CHRONIC; SILICOSIS (DISABLING LUNG DISEASE).
LIVER, KIDNEY AND BLOOD INJURY. ENHANCES NEUROTOXICITY (SYNERGISTIC
EFFECT RESULTED IN PERIPHERAL NEUROPATHY). PROLONGED & REPEATED
OVEREXPOSURE: PERMANENT BRAIN & NERVOUS SYSTEM DAMAGE.
CONCENTRATING & INHALING PRODUCT MAY BE HARMFUL OR FATAL.
Medical Cond Aggravated by Exposure:PRE-EXISTING RESPIRATORY CONDITIONS
MAY BE AGGRAVATED BY EXPOSURE TO CRYSTALLINE SILICA.
======================= First Aid Measures =======================
First Aid:INGEST: DONT INDUCE VOMITING. CALL POISON CTR/EMERG ROOM/DR
IMMED. INHAL:REMOVE TO FRESH AIR IMMED. IF BREATHING STOPPED, GIVE
ARTIF RESPRTN. KEEP WARM & QUIET. GET MED AID IMMED. EYE: FLUSH
W/WATER 1 5 MIN, LIFTING EYELIDS. GET MED AID. SKIN: REMOVE CONTAM
CLOTHES. WASH AFFECTED AREA W/SOAP & WATER. GET MED AID IF IRRIT
PERSISTS. NOTE TO DR:DIRECT TREATMENT AT CLINICAL CONDITION &
SYMPTOM CONTROL.
===================== Fire Fighting Measures =====================
Flash Point:24.0F,-4.4C
Autoignition Temp:Autoignition Temp Text:572 F
Lower Limits:0.8
Upper Limits:10.0
Extinguishing Media:NFPA CLASS B EXTINGUISHERS (CO2, DRY CHEMICAL,
ALCOHOL FOAM) FOR FLAMMABLE LIQ. POLYMER FOAM PREFERRED FOR LARGE
FIRES.
Fire Fighting Procedures:WATER MAY BE INEFFECTIVE, USE TO COOL EXPOSED
CONTAINERS (FOG NOZZLES PREFERRED) TO PREVENT PRESSURE BUILDUP,
AUTOIGNITION OR EXPLOSION WHEN EXPOSED TO HEAT.
Unusual Fire/Explosion Hazard:DURING EMERGENCY CONDITIONS, OVEREXPOSURE
TO DECOMPOSITION PRODUCTS MAY BE HEALTH HAZARD. SYMPTOMS MAY NOT BE
IMMEDIATELY APPARENT. GET MEDICAL AID. FLAMMABLE.
================== Accidental Release Measures ==================
Spill Release Procedures:KEEP SPECTATORS AWAY. ELIMINATE ALL IGNITION
SOURCES. DIKE & CONTAIN WITH INERT MATERIAL (SAND, EARTH, ETC).
TRANSFER LIQUID OR USED ABSORBENT TO COVERED METAL CONTAINER. USE
NON-SPARKING TOOLS. PREVE NT SEWER, STREAM, OR GROUNDWATER
CONTAMINATION.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 115 F. STORE LARGE
QUANTITIES IN COMPLIANCE WITH OSHA 29 CFR 1910.106. DO NOT TAKE
INTERNALLY. DO NOT BREATHE SANDING DUST.
Other Precautions:CLOSE CONTAINER AFTER EACH USE. DO NOT WASH & REUSE
EMPTY CONTAINER FOR ANY PURPOSE. GROUND & BOND CONTAINERS TO
RECEIVING CONTAINER. DO NOT WELD, BRAZE, OR CUT ON EMPTY CONTAINER.
NEVER USE PRESSURETO EMPTY. DRUM IS NOT A PRESSURE VESSEL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF VENTD,MAY NOT REQ RSPRTR.IN RESTRICTD
VENT,NIOSH CHEM CARTRIDGE RSPRTR MAY BE REQ'D.SPRAYNG,MECHAN
PREFILTER MAY ALSO BE REQ'D.CONFIND AREAS,USE AIR SUPPLD RSPRTR.SEE
OSHA 29CFR1910.134"RESP PROTEC T"&"RESP PROTECT-MANUAL &
GUIDELINE"AIHA
Ventilation:LOCAL EXHAUST VENT TO KEEP BELOW TLV. REMOVE DECOMPOSITION
PRODUCT. SEE "INDUST VENT-MANUAL RECOMMENDED PRACTICES" ACGIH
Other Protective Equipment:NOT LIKELY TO BE NEEDED.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:175 TO 289F
Melt/Freeze Pt:M.P/F.P Text:-50F,-46C
Decomp Temp:Decomp Text:1832F,1000C
Vapor Pres:70 @ 68F
Vapor Density:> AIR
Spec Gravity:1.0
pH:4-7
Viscosity:67 - 77 KU
Evaporation Rate & Reference:SLOWER THAN DIETHYL ETHER
Solubility in Water:SLIGHT IN WATER
Appearance and Odor:LIQUID, SOLVENT ODOR
Percent Volatiles by Volume:42
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS OR ALKALINE MATERIALS. OXIDIZING MATERIALS.
Stability Condition to Avoid:AVOID EXCESSIVE HEAT (>115F) AND SOURCES
OF IGNITION.
Hazardous Decomposition Products:BURNING, INCLUDING WHEN HEATED BY
WELDING OR CUTTING, WILL PRODUCE SMOKE, CARBON MONOXIDE & CARBON
DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH FEDERAL, STATE, &
LOCAL LAWS OR REGULATIONS. THIS PRODUCT, IF DISCARDED DIRECTLY,
WOULD BE CLASSIFIED A HAZARDOUS WASTE BASED ON ITS IGNITABILITY
CHARACTERISTIC (FLASH POINT 140F OR LESS). PROPER RCRA
CLASSIFICATION: D001.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:BIO JET 7
CAGE:JETNC
CAGE:JETNC
============= Composition/Information on Ingredients =============
Ingred Name:ALKOXYLATED LINEAR ALCOHOLS POLY (OXYETHYLENE), CONTAINING
INGREDIENTS 2-4
RTECS #:9999999ZZ
Fraction by Wt: 1%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:POLY(OXYETHYLENE)-MONOHEXYLETHER
CAS:52232-09-4
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:POLY(OXYETHYLENE)-MONOOCTYLETHER
CAS:37311-02-7
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:POLY(OXYETHYLENE)-MONODECYLETHER
CAS:37251-67-5
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:FRAGRANCE
Fraction by Wt: 1%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:BLUE DYE
CAS:41611-76-1
Fraction by Wt: 1%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SODIUM NITRITE (CERCLA)
CAS:7632-00-0
RTECS #:RA1225000
Fraction by Wt: 1%
OSHA PEL:N/K
ACGIH TLV:N/K
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:VIABLE BACTERIAL CULTURES, LARGELY CONTAINING INGREDIENT 9
Fraction by Wt: >95%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: SKIN: POSSIBILITY OF DERMAL
SENSITIVITY. EYES: DUST OR MIST COULD INFECT EYES. ORGANISMS USED
ARE NON-PATHOGENIC, BUT CAN CAUSE INFECTION WHEN IN CONTACT WITH
OPEN WOUNDS. THESE ORGANISMS ARE S USCEPTIBLE TO MANY COMMONLY USED
ANTIBIOTICS. CHRONIC: NONE KNOWN.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEATLH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:SKIN: WASH WITH SOAP AND WATER. WASH CLOTHING BEFORE REUSE.
EYES: FLUSH WITH WATER FOR AT LEAST 15 MINUTES. CONTACT MD.
INHALATION: REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE OXYGEN OR
ARTIFICIAL RE SPIRATION) . INGESTION: CALL MD IMMEDIATELY .
===================== Fire Fighting Measures =====================
Extinguishing Media:USE WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:WHERE POSSIBLE, FLUSH DOWN DRAIN TO WASTE
TREATMENT SEWER. OTHERWISE, ON SMALL SPILLS, USE CHEMICAL ABSORBENT
AND SWEEP UP. FOR LARGE SPILLS, CONFINE AND COLLECT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTACT WITH EYES.
Other Precautions:TO MAINTAIN PRODUCT ACTIVITY, KEEP CONTAINER CLOSED.
AVOID PROLONGED EXPOSURE TO TEMPERATURES ABOVE 115F, AND KEEP FROM
FREEZING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED FOR RECOMMENDED USE. AVOID
CREATING AEROSOLS IN POORLY VENTILATED AREAS. USE NIOSH/MSHA
APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:NORMAL ROOM VENTILATION.
Other Protective Equipment:AS DETERMINED/RECOMMENDED BY FEDERAL,
STATE/LOCAL REGULATIONS. ANSI APPROVED EMERGENCY EYEWASH AND DELUGE
SHOWER .
Work Hygienic Practices:WASH HANDS THOROUGHLY WITH SOAP AND WATER AFTER
USE.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:= WATER
Vapor Density:= WATER
Spec Gravity:1
Evaporation Rate & Reference:= WATER
Solubility in Water:99%
Appearance and Odor:MEDIUM BLUE LIQUID, WITH PERFUMED ODOR
Percent Volatiles by Volume:=WATER
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS OR ALKALI COMPOUNDS MAY INACTIVATE BIOLOGICAL CULTURES.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL OF THIS MATERIAL RINSATES, MIXTURES,
AND SPILL RESIDUE MUST BE IN ACCORDANCE WITH ALL LOCAL, STATE, AND
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:RAPID ACCESS FIXER REPLENISHER SOLUTION
CAGE:66162
CAGE:66162
============= Composition/Information on Ingredients =============
Ingred Name:AMMONIUM THIOCYANATE (SARA III)
CAS:1762-95-4
RTECS #:XK7875000
Fraction by Wt: 10%
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:AMMONIUM THIOSULFATE
CAS:7783-18-8
RTECS #:XN6465000
Fraction by Wt: 20%
Ingred Name:ACETIC ACID (SARA III)
CAS:64-19-7
RTECS #:AF1225000
Fraction by Wt: 5%
OSHA PEL:10 PPM
ACGIH TLV:10 PPM/15 STEL; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Effects of Overexposure:AVOID CONTACT W/EYES,SKIN/CLOTHING. CONTACT
W/ANY TISSUE CAN CAUSE IRRITATION.
======================= First Aid Measures =======================
First Aid:EYES:IMMED FLUSH W/PLENTY OF H*2O FOR @ LEAST 15 MIN. GET MED
ATTN. SKIN:WASH THOROUGHLY W/SOAP & H*2O.
===================== Fire Fighting Measures =====================
Fire Fighting Procedures:NON-COMBUSTIBLE LIQUID
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
RINSE & MOP SOILED AREA W/FRESH H*2O.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE CONTAINERS IN DRY AREA NOT BELOW
40F (4C) OR ABOVE 85F (30C).
============= Exposure Controls/Personal Protection =============
Respiratory Protection:N/A (MFR)
Ventilation:MECHANICAL (GENERAL) VENTILATION.
Supplemental Safety and Health
PH:4.7.
================== Physical/Chemical Properties ==================
Spec Gravity:1.15
Solubility in Water:COMPLETELY
Appearance and Odor:VERY PALE YELLOW-GREEN LIQUID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CHLORATES,NITRATES,NITRITES.
Stability Condition to Avoid:STRONG OXIDIZERS
Hazardous Decomposition Products:AMMONIA,SULFIDE TO TRIOXIDE GASES,
HYDROGEN SULFIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:FLUSH WASTE, SPENT/EXCESS FIXER DOWN SANITARY
SEWER DRAIN W/COPIOUS AMTS OF H*2O. DISPOSE IAW FEDERAL, STATE, &
LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:941 HOLE & DENT PLUG
Preparer's Name:S ABDUL RAZZAK
CAGE:16522
CAGE:16522
============= Composition/Information on Ingredients =============
Ingred Name:2,4,6-TRI(DIMETHYLAMINOMETHYL)PHENOL, DMP-30
CAS:90-72-2
RTECS #:SN3500000
Fraction by Wt: <5%
Ingred Name:MERCAPTAN POLYMER (TERMINATED)
Fraction by Wt: <25%
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT): 2.6 G/KG (SEE SUP)
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: IRRITATION & ABSORPTION. EYES:
IRRITATION. INHALATION: RESPIRATORY TRACT IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SKIN: IRRITATION & ABSORPTION. EYES:
IRRITATION. INHALATION: RESPIRATORY TRACT IRRITATION.
Medical Cond Aggravated by Exposure:SKIN DISORDERS
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MINS. SKIN:
WASH W/PLENTY OF SOAP & WATER. INHALATION: REMOVE TO FRESH AIR.
INGESTION: DON'T INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WATER SPRAY, FOAM, CO2, OR DRY CHEMICAL
Fire Fighting Procedures:COOL EXPOSED AREA W/WATER SPRAY. WEAR
SELF-CONTAINED BREATHING APPARATUS IN CONFINED AREAS.
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN AREA IN NORMAL MANNER.
======================Handling and Storage ======================
Handling and Storage Precautions:MIXING LARGE MASSES OF MATERIAL MAY
GENERATE EXCESSIVE HEAT DUE TO EXOTHERMIC REACTION.
Other Precautions:AVOID CONTACT W/EYES & SKIN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AS REQUIRED.
Ventilation:LOCAL EXHAUST IF HEATED >100F.
Work Hygienic Practices:WASH HANDS W/SOAP & WATER AFTER EVERY USAGE.
Supplemental Safety and Health
LD50 DATA IS FOR MERCAPTAN-TERMINATED POLYMER.
================== Physical/Chemical Properties ==================
Spec Gravity:1.9
Solubility in Water:INSOLUBLE
Appearance and Odor:SILVER GREY W/MERCAPTAN ODOR.
Percent Volatiles by Volume:0%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:CO2, CO, OXIDES OF SULFUR, & HYDROGEN
SULFIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:FORMULA 2150 GUM REMOVER
CAGE:58396
CAGE:58396
============= Composition/Information on Ingredients =============
Ingred Name:METHANE, CHLORODIFLUORO-; (CHLORODIFLUOROMETHANE)
CAS:75-45-6
RTECS #:PA6390000
Fraction by Wt: 100%
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM
Ozone Depleting Chemical:2
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NOSE:MINIMAL EFT <1000 PPM; DIZZ,
DROWSINESS, & THROAT IRRIT AT LEVEL ABOVE 1000 PPM. SKIN: CONTACT
WITH LIQUID MAY CAUSE FROSTBITE. INGEST: SLIGHTLY TOXIC. INGESTION
OF LRG QTYS MAY CAUSE DROWSINESS, & UNCONSCIOUSNESS, STOMACH
CRAMPS, PAIN, NAUSEA, VOMITING, AND DIARRHEA. EYES: CAN CAUSE
SLIGHT TOMOD(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:IRRIT W/POSS CORNEA INJURY.
CHLOROFLUOROCARBON (CFC) MATLS HAVE PRODUCED SENSIT OF MYOCARDIUM
TO EPINEPHRINE IN LAB ANIMALS & COULD HAVE A SIMILAR EFT IN HUMANS.
ADRENOMIMETICS (E.G. EPINEPHR INE) MAY BE CONTRAINDICATED EXCEPT
FOR LIFE-SUSTAINING USES IN HUMANS ACUTELY/CHRONICALLY EXPOSED
(SUPP DATA)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR, IF BRTHG IS DIFFICULT, ADMINISTER
OXYGEN. IF BREATHING STOPS GIVE ARTF RESP. GET MED ATTN. INGEST:
NOT CONSIDERED A POTENTIAL ROUTE OF EXPOSURE. GET MD IMMED . SKIN:
FLUSH WITH WATER FOR AT LEAST 15 MIN, LIFTING UPPER AND LOWER LIDS.
GET MEDICAL ATTENTION. SKIN: WASH EXPOSED SKIN AREAS WITH SOAP AND
WATER. TREAT FOR FROSTBITE IF NECESSARY.
===================== Fire Fighting Measures =====================
Flash Point Method:TOC
Flash Point:NONE
Extinguishing Media:FOAM, DRY CHEMICAL, CO*2.
Fire Fighting Procedures:KEEP CNTNRS COOL, USE EQUIP/SHIELDING TO PROT
PERSONNEL AGAINST BURST/RUPTURE/VENTING CNTNRS. USE NIOSH/MSHA
APPRVD PRESS DEMAND SCBA & FULL PROT EQUIP .
Unusual Fire/Explosion Hazard:AT ELEVATED TEMPERATURES (>120F)
CONTAINERS MAY VENT, RUPTURE OR BURST. THERMAL DECOMPOSITION
PRODUCTS MAY INCLUDE HCL AND PHOSGENE .
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN UP AREA BY MOPPING OR WITH ABSORBENT
MATERIALS AND PLACE IN CLOSED CONTAINERS FOR DISPOSAL. CONTACT
FEDERAL, STATE OR LOCAL AUTHORITIES FOR APPROVED DISPOSAL
PROCEDURES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE AT TEMPERATURES ABOVE
120F. SPRAY SHLD NOT BE DIRECTED TOWARD FACE/EYES, OPEN FLAME/OTHER
SOURCE OF IGNITION.
Other Precautions:DO NOT EAT DRINK/SMOKE IN WORK AREA. READ & FOLLOW
THE DIRECTIONS ON THE PROD LABEL. NO SMOKING IN AREA OF USE. DO NOT
USE IN GEN VICINITY OF ARC WELDING, OPEN FLAMES/HOT SURF. HEAT
AND/OR UV RADIATIO N MAY CAUSE THE FORMATION (SUPP DATA)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED ORGANIC VAPOR TYPE
RESPIRATOR ACCEPTABLE IF CONCENTRATION IS ABOVE 1000 PPM.
Ventilation:DO NOT USE IN CONFINED SPACES.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH HANDS BEFORE EATING.
Supplemental Safety and Health
EFTS OF OVEREXP: TO CFC'S . OTHER PREC: OF CHLORIDES, FLUORIDES, AND/OR
PHOSGENE .
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:-41F,-40C
Vapor Pres:125
Vapor Density:3.03
Spec Gravity:1.2 (H*2O-1)
Solubility in Water:0.30% @ 77F
Appearance and Odor:SLIGHT ETHERAL ODOR.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALKALI METALS, ALKALINE EARTH METALS, POWDERED ALUMINUM, BERYLIUM, ZINC
ETC.
Stability Condition to Avoid:DO NOT EXPOSE TO OPEN FLAMES OR TO
TEMPERATURES ABOVE 120F.
Hazardous Decomposition Products:HYDROCHLORIC AND HYDROFLUORIC ACIDS
AND POSSIBLY CARBONYL HALIDES. PHOSGENE .
==================== Disposal Considerations ====================
Waste Disposal Methods:WHEN USED PROPERLY AEROSOL PROD DO NOT GENERATE
HAZ WASTE. EMPTY DE-PRESSURIZED CNTNRS CANNOT BE REUSED & SHOULD BE
WRAPPED & PUT IN A PERMITTED WASTE MANAGEMENT FACILITY. CONSULT
FEDERAL, STATE, AND LOCAL DISPOSAL AUTHORITIES FOR APPRVD DISP
PROC.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:DRAIN BLOCKER DRAIN PLUG, PLR203
CAGE:1JA49
CAGE:1JA49
============= Composition/Information on Ingredients =============
Ingred Name:POLYURETHANE ELASTOMER
Fraction by Wt: 100%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPDAT:TOLUENE DIISOCYANATE OR DIPHENYLMETHANE
DIISOCYANATE, HYDROGEN CYANIDE, ACROLEIN AND OXIDES OF NITROGEN.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE AND CHRONIC:NOT APPLICABLE.
SIGNS & SYMPTOMS:NOT APPLICABLE.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD IMMEDIATELY . INHAL:REMOVE TO FRESH AIR.
SUPPORT BREATHING (GIVE O*2/ARTF RESP) . EYES:IMMEDIATELY FLUSH
W/POTABLE WATER FOR A MINIMUM OF 15 MINUTES, SEEK ASSISTANCE FROM
MD. SKIN:FLUSH W/COPIOUS AMOUNTS OF WATER. CALL MD .
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER, CHEMICAL FOAM, DRY CHEMICAL OR CO*2.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. AVOID BRTHG SMOKE, FUMES & DECOMP PRODS. USE WATER SPRAY TO
DRENCH SMOLDERING ELASTOMER. PROD MAY (SUPDAT)
Unusual Fire/Explosion Hazard:NOT APPLICABLE.
================== Accidental Release Measures ==================
Spill Release Procedures:PICK UP AND HANDLE AS ANY OTHER INERT SOLID
MATERIAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:ALWAYS USE W/YELLOW SIDE UP. AFTER
USE, ALWAYS DECONTAM PROD. WHEN NOT IN USE PROD SHOULD BE STORED IN
SHELTERED COMPARTMENT (I.E. OUT OF SUNLIGHT).
Other Precautions:PRODUCT SHOULD BE STORED WITH PLASTIC FILM APPLIED
LYING FLAT OR ROLLED UP.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN . NOT APPLICABLE.
Ventilation:NONE.
Other Protective Equipment:NONE REQUIRED.
Work Hygienic Practices:NONE REQUIRED.
Supplemental Safety and Health
SPEC GRAV:1.05-1.26 (H*2O=1). VP:MELTS >380F, >193C. WILL DEGRADE ABOVE
300F (150C). FIRE FIGHT PROC:MELT AFTER IGNIT TO FORM FLAM LIQS.
BURNING PRDCES INTENSE HEAT, DENSE SMK & TOX GASES SUCH AS CARB ON
MONOXIDE, OXIDES OF NITROGEN & TRACES OF HYDROGEN CYANIDE. HAZ
DECOMP PRODS:MONOXIDE, & MAY CNTN TRACES OF (ING 2)
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:SUPP DATA
Spec Gravity:SUPP DATA
Solubility in Water:INSOLUBLE
Appearance and Odor:RUBBER-LIKE SUBSTANCE IN A MAT FORM, YELLOW AND
ORANGE IN COLOR. NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
PRODUCT MAY BE AFFECTED BY STRONG ACIDS OR BASES.
Stability Condition to Avoid:NOT APPLICABLE.
Hazardous Decomposition Products:DECOMP THRU BURNING PRDCES FUMES
CONSISTING OF ORG PARTICULATES, GASEOUS HYDROCARBS, CARBON DIOXIDE,
CARBON (SUPP DATA)
==================== Disposal Considerations ====================
Waste Disposal Methods:NOT CONSIDERED A HAZARDOUS MATERIAL. DISPOSE OF
MATERIAL ACCORDING TO FEDERAL, STATE AND LOCAL LAWS.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:COM-4D, LEAD-ACID BATTERY
CAGE:20038
CAGE:64812
CAGE:0FTM0
CAGE:0K4U5
CAGE:20038
CAGE:79542
============= Composition/Information on Ingredients =============
Ingred Name:LEAD
CAS:7439-92-1
RTECS #:OF7525000
Fraction by Wt: 60%
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.05 MG/M3;1910.1025
ACGIH TLV:0.15 MG/M3;DUST 9293
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:ANTIMONY
CAS:7440-36-0
RTECS #:CC4025000
Fraction by Wt: 2%
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.5 MG/M3
ACGIH TLV:0.5 MG/M3; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ARSENIC
CAS:7440-38-2
RTECS #:CG0525000
Fraction by Wt: 0.2%
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.5 MG/M3 (AS)
ACGIH TLV:0.01,A1 MG/M3; 9394
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:CALCIUM
CAS:7440-70-2
RTECS #:EV8040000
Fraction by Wt: 0.2%
Other REC Limits:NONE SPECIFIED
Ingred Name:TIN
CAS:7440-31-5
RTECS #:XP7320000
Fraction by Wt: 0.2%
Other REC Limits:NONE SPECIFIED
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3; 9293
Ingred Name:SULFURIC ACID (SARA III)
CAS:7664-93-9
RTECS #:WS5600000
Fraction by Wt: 10-30%
Other REC Limits:NONE SPECIFIED
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:POLYPROPYLENE (CASE MATERIAL)
CAS:9003-07-0
Fraction by Wt: 5-10%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:EYES: SEVERE IRRITATION, BURNS, CORNEA
DAMAGE, BLINDNESS. SKIN: SEVERE IRRITATION, BURNS, ULCERATION.
INHALATION: SEVERE IRRITATION OF RESPIRATORY TRACT AND LUNGS.
INGESTION: ACID MAY CAUSE SEVERE IRR ITATION OF MOUTH, THROAT,
ESOPHAGUS, STOMACH. LEAD MAY CAUSE ABDOMINAL PAIN, NAUSEA,
VOMITING, DIARRHEA,SEVERE CRAMPING.
Explanation of Carcinogenicity:ARSENIC IS LISTED BY IARC, NTP, & OSHA
AS A CARCINOGEN. LEAD IS CONSIDERED A PROBABLE CARCINOGEN BY NTP.
Effects of Overexposure:EYES; SEVERE IRRITATION, BURNS, CORNEA DAMAGE,
BLINDNESS. SKIN: SEVERE IRRITATION, BURNS, ULCERATION. INHALATION:
SEVERE IRRITATION OF RSPIRATORY TRACT AND LUNGS. INGESTION: SEVERE
IRRITATION OF MOUTH , THROAT, ESOPHAGUS, STOMACH, ABDOMINALPAIN,
NAUSEA, VOMITING, DIARRHEA, CRAMPING, HEADACHE, ANEMIA, KIDNEY
DAMAGE.
Medical Cond Aggravated by Exposure:PULMONARY CONDITIONS, SKIN
DISEASES, LIVER, KIDNEY AND NEUROLOGIC DISEASES.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH LARGE AMOUNTS OF WATER. GET MEDICAL
ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING. WASH AREA WITH LARGE
AMOUNTS OF WATER. IF SYMPTOMS DEVELOP, GET MEDICAL ATTENTION.
INHALATION: MOVE TO FRESH AIR. IF BREATHING DIFFICULT, GIVE
OXYGEN. GET MEDICAL ATTENTION. INGESTION: ACID: GIVE LARGE AMOUNTS
OF WATER. DO NOT INDUCE VOMITING. GET MEDICAL ATTENTION. LEAD: GET
MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Lower Limits:4.1 (H2 GAS)
Upper Limits:74.2(H2 GAS)
Extinguishing Media:CARBON DIOXIDE, FOAM, DRY CHEMICAL, HALOGEN.
Fire Fighting Procedures:IF ON CHARGE, SHUT OFF POWER. WATER APPLIED TO
ACID GENERATES HEAT AND CAUSES IT TO SPLATTER. WEAR ACID RESISTANT
CLOTHING.
Unusual Fire/Explosion Hazard:HIGHLY FLAMMABLE HYDROGEN GAS IS
GENERATED DURING CHARGING AND OPERATION OF BATTERIES. TO AVOID FIRE
OR EXPLOSION, KEEP SPARKS OR OTHER IGNITION SOURCES AWAY.
================== Accidental Release Measures ==================
Spill Release Procedures:STOP LEAK. CONTAIN SPILL. ABSORB SMALL SPILLS
WITH DRY SAND, EARTH, VERMICULITE. DO NOT USE COMBUSTIBLE
MATERIALS. NEUTRALIZE WITH SODA ASH, SODIUM BICARBONATE, LIME, ETC.
DO NOT ALLOW DISCHARGE OF UN NEUTRALIZED ACID TO SEWER.
Neutralizing Agent:SODA ASH, SODIUM BICARBONATE, LIME.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY, WELL-VENTILATED
AREA WITH IMPERVIOUS SURFACES AND ADEQUATE CONTAINMENT IN EVENT OF
SPILLS. SEPARATE FROM INCOMPATIBLE MATERIALS.
Other Precautions:BATTERIES SHOULD BE STORED UNDER ROOF FOR PROTECTION
AGAINST ADVERSE WEATHER CONDITIONS. AVOID DAMAGE TO CONTAINERS.
KEEP AWAY FROM FIRE, SPARKS AND HEAT. STORE AND HANDLE ONLY IN
AREAS WITH ADEQUATE WATER SUPPLY AND SPILL CONTROL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED UNDER NORMAL CONDITIONS. WHEN
CONCENTRATIONS OF SULFURIC ACID MISTS ARE KNOWN TO EXCEED PEL, USE
NIOSH OR MSHA-APPROVED RESPIRATORY PROTECTION.
Ventilation:USE MECHANICAL (GENERAL) OR LOCAL EXHAUST VENTILATION TO
MEET TLV REQUIREMENTS. COMPONENTS MUST BE ACID-RESISTANT.
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
INDUSTRIAL-TYPE WORK CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:WASH AFTER HANDLING AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
HANDLE BATTERIES CAUTIOUSLY TO AVOID SPILLS. MAKE CERTAIN VENT CAPS ARE
ON SECURELY. AVOID CONTACT WITH INTERNAL COMPONENTS.
================== Physical/Chemical Properties ==================
HCC:C1
Boiling Pt:=95.C, 203.F
Vapor Pres:10
Vapor Density:>1
Spec Gravity:1.23-1.35
pH:<2.0
Evaporation Rate & Reference:<1 (BU AC = 1)
Solubility in Water:COMPLETE FOR ACID
Appearance and Odor:MANUFACTURED ARTICLE. NO ODOR. ELECTROLYTE IS A
CLEAR LIQUID WITH PUNGENT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, STRONG REDUCING AGENTS, COMBUSTIBLES, ORGANIC
MATERIAL, METALS, SULFUR TRIOXIDE GAS, WATER.
Stability Condition to Avoid:PROLONGED OVERCHARGE, SOURCES OF IGNITION,
SHORT CIRCUITING.
Hazardous Decomposition Products:CONTACT WITH METALS MAY PRODUCE TOXIC
SULFUR DIOXIDE FUMES AND MAY RELEASE FLAMMABLE HYDROGEN GAS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF NEUTRALIZED WASTE IN ACCORDANCE WITH
LOCAL, STATE AND FEDERAL REGULATIONS. SEND SPENT BATTERIES TO
SECONDARY LEAD SMELTER FOR RECYCLING.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Preparer's Name:DOD HMIS/DGSC-SSH
CAGE:JO772
CAGE:14153
CAGE:JO772
============= Composition/Information on Ingredients =============
Ingred Name:ASBESTOS, CHRYSOTILE
CAS:12001-29-5
RTECS #:CI6478500
OSHA PEL:0.2 FIBERS/CC
ACGIH TLV:2 FIBERS/CC; A1;9192
Ingred Name:ASBESTOS & NATURAL/SYNTHETIC RUBBER & NICKEL COMPOSITION
RTECS #:9999999ZZ
Ingred Name:GENERIC "MSDS". SPECIFIC ASBESTOS TYPE NOT KNOWN. ONE
CITED IS ASSUMED. INFORMATION BASED ON SEGMENT "M" OF "DLSC TIR"
RTECS #:9999999ZZ
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: NO ACUTE EFFECTS ARE KNOWN;
CHRONIC: DUST FROM ABRASIVE ACTIONS(EG. CUTTING, MACHINING,
FILING, ETC.) MAYCONTAIN ASBESTOS FIBERS. CHRONIC OVEREXPOSURE
TO AIRBORNE FIBERS MAY LEAD TO ASBESTOSIS & MESOTHELIOMA.
SMOKINGCOMBINED W/FIBER INHALATION GREATLY INCREASES LUNG
CANCER RISK!
Explanation of Carcinogenicity:OVEREXPOSURE TO AIRBORNE CONCENTRATIONS
OF ASBESTOS MAY LEAD TO ASBESTOSIS AND MESOTHELIOMA.
Effects of Overexposure:INHAL: INHALATION OF AIRBORNE DUST CONTAINING
ASBESTOS FIBERS ON REPEATED EXPOSURE MAY CAUSE OR CAN LEAD TO
ASBESTOSIS/ MESOTHELIOMA; SKIN: N/K; EYE: POTENTIAL IRRITATION
FROM AIRBORNE DUST; INGEST: N/K.
Medical Cond Aggravated by Exposure:RESPIRATORY DEFICIENCIES DUE TO
REPEATED INHALATION OF AIRBORNE FIBERS.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. OBTAIN MEDICAL ADVICE; SKIN:
WASH EXPOSED AREA WITH SOAP & WATER; EYE: FLOOD W/ WATER. IF
IRRITATION OCCURS, GET MEDICAL ATTN; INGEST: CONSULT A
PHYSICIAN; OTHER: CHANGE CLOTHING AS REQUIRED TO AVOIDCARRYING
DUST PARTICLES INTO OTHER AREAS
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:MATERIAL IS NOT FLAMMABLE ; USE MEDIA APPROPRIATE
FOR SURROUNDING FIRE.
Fire Fighting Procedures:COMBUSTION PRODUCTS OF THIS MATERIAL MAY BE
TOXIC. USE A SELF-CONTAINED BREATHING APPARATUS WHEN FIGHTING FIRES
INVOLVING CHEMICAL PRODUCTS.
Unusual Fire/Explosion Hazard:NONE KNOWN
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION. VACUUM OR WET
CLEAN IF DUST IS INVOLVED. ANY VACUUM SYSTEM SHOULD BE EQUIPPED W/
AN OUTLET "HEPA" FILTER TO PREVENT REINTRODUCING ASBESTOS FIBERS TO
THE ATMOSPHERE.
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLE IN A MATTER TO MINIMIZE
FORMATION OR RETENTION OF AIRBORNE DUST. USE PROPER PERSONAL
PROTECTION FOR TASK AT HAND. CHECK W/YOUR SAFETY OFFICE!!!
Other Precautions:AS MANUFACTURED, LOCKED-IN ASBESTOS DOES NOT PRESENT
A HAZARD. ONLY WHEN THE ITEM IS SUBJECTED TO ABRASIVE ACTIONS &
DUST IS GENERATED, THEN ASBESTOS FIBERS MAY BE RELEASED & BECOME
AIRBORNE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF EXPOSURES EXCEED ESTABLISHED LIMITS, A
NIOSH/MSHA APPROVED RESPIRATOR FOR ASBESTOS SHOULD BE USED.
CONSULT YOUR SAFETY OFFICE/IH PERSONNEL FOR GUIDANCE FOR THE TASK
AT HAND.
Ventilation:LOCAL EXHAUST IS RECOMMENDED IN SITUATIONS WHERE DUST IS
GENERATED BY ABRASIVE ACTIONS, ABRASION OR OTHER MEANS.
Other Protective Equipment:AS REQUIRED FOR TASK AT HAND, AND THE
GUIDANCE SET FORTH BY YOUR SAFETY OFFICE OR IH PERSONNEL
Work Hygienic Practices:DONOT INHALE DUST CREATED BY ABRADING ACTIONS.
USE FULL PROTECTION AGAINST AIRBORNE FIBERS. AVOID AIRBORNE DUST
CREATION
Supplemental Safety and Health
GENERIC "MSDS" CREATED FOR "NSN" IDENTIFIED BY "DISC" AS CONTAINING
ASBESTOS.WHEN A MANUFACTURER'S SPECIFIC "MSDS" IS PROVIDED FOR
MATERIAL PROCURED UNDER THIS NSN, THIS GENERIC "MSDS" WILL BE
REMOVED.
================== Physical/Chemical Properties ==================
HCC:T6
Evaporation Rate & Reference:NONE
Solubility in Water:NOT SOLUBLE
Appearance and Odor:MANUFACTURED COMMODITY DESCRIBED BY LOGISTICS:
"ITEM-NAME"
Percent Volatiles by Volume:NONE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:NONE KNOWN
==================== Disposal Considerations ====================
Waste Disposal Methods:DUST SHOULD BE HANDLED AS A HAZARDOUS AIR
POLLUTANT I/A/W 40CFR61 SUBPART "M" PERTAINING TO ASBESTOS. USE
LANDFILLS APPROVED FOR ASBESTOS DISPOSAL. NOTE IF ITEM UNDER
CONSIDERATION FOR DISPOSAL IS "FRIABLE OR NON-FRIABLE".
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MS-143 FLUOROCARBON RELEASE AGENT
CAGE:18598
CAGE:18598
============= Composition/Information on Ingredients =============
Ingred Name:1,1,2-TRICHLORO-1,2,2-TRIFLUOROETHANE (FREON 113) (SARA
III)
CAS:76-13-1
RTECS #:KJ4000000
Fraction by Wt: 9.7%
OSHA PEL:1000PPM/1250STEL
ACGIH TLV:1000PPM/1250STEL9192
Ozone Depleting Chemical:1
===================== Hazards Identification =====================
Effects of Overexposure:INHALATION OF VAPOR:
DIZZINESS/NARCOSIS/ANESTHESIA/SUFFOCATION. EYE: MINOR IRRIT. SKIN:
DRYNESS.
======================= First Aid Measures =======================
First Aid:INHALATION: MOVE TO FRESH AIR. IF NECESSARY, GIVE ARTIFICIAL
RESP OR OXYGEN. DON'T GIVE EPINEPHRINE OR SIMILAR DRUGS AS SUCH
DRUGS MAY INDUCE VENTRICULAR ARRHYTHMIA. PYROLYZED FUME INHALATION.
NORMAL RECOVERY W/IN 1-2 DAYS. EYES: FLUSH W/WATER.
===================== Fire Fighting Measures =====================
Flash Point:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. WIPE UP SPILL AND DISPOSE TO
LANDFILL. WASH HANDS WITH SOAP AND WATE
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T STORE NEAR SOURCES OF HEAT.
ROTATE STOCK TO SHELF LIFE OF 1 YEAR.
Other Precautions:AVOID CONTAMINATION OF TOBACCO OR SMOKING WITH
CONTAMINATED HANDS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:PROVIDE LOCAL EXHAUST VENTTILATION TO KEEP
BELOWTLV.
Ventilation:LOCAL EXHAUST FUMES IF HEATING >400F.
Other Protective Equipment:DON'T ALLOW LIQUID TO SKIN AND EYES.
Supplemental Safety and Health
MSDS DATE: 04/10/85
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:118F
Vapor Pres:334
Vapor Density:2.9
Spec Gravity:1.36
Evaporation Rate & Reference:(N- BUAC =1 ): 1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:MILKY DISPERSION WITH FAINT SOLVENT ODOR.
Percent Volatiles by Volume:97%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
FINELY DIVIDED REACTIVE METALS.
Stability Condition to Avoid:DON'T USE NEAR OPEN FLAMES OR RED HOT
SURFACES.
Hazardous Decomposition Products:HALOGENS ACIDS, PHOSGENE IN SMALLER
AMTS/PERFLUOROCARBONS.
Conditions to Avoid Polymerization:DON'T SMOKE W/CONTAMINATED TOBACCO
OR HANDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:RECLAIM SOLVENTS BY FILTRATION & DISTILLATION.
DISPOSAL SERVICE TO LANDFILL IS APPROPRIATE AS LOCAL REGULATIONS
PERMIT. CONSULT LOCAL WASTE DISPOSAL CONTRACTOR.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:320-M-3,INDUSTRIAL ENAMEL,WHITE
CAGE:HO292
CAGE:3N081
CAGE:HO292
============= Composition/Information on Ingredients =============
Ingred Name:140 SOLVENT (%-BY VOLUME-10)(VAPOR PRESSURE:O.5 MMHG @
60.0F.)
ACGIH TLV:25 PPM (MFR)
Ingred Name:NAPHTHA (PETROLEUM SPIRITS OR BENZIN)
CAS:8030-30-6
RTECS #:SE7555000
OSHA PEL:100 PPM
===================== Hazards Identification =====================
Effects of Overexposure:ACUTE: INHALATION-ANESTHETIC. IRRIT OF
RESPIRATORY TRACT/ACUTE NERVOUS SYS DEPRESSION (SEE OTHR PREC
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. RESTORE BREATHING. CONSULT
FOR 15 MIN. SKIN-WASH W/SOAP & H*2O. IN BOTH CASES,CONSULT
PHYS/CALL EMER #. INGEST:DONT INDUCE VOMIT,CONSULT PHYS/CALL EMER
#
===================== Fire Fighting Measures =====================
Flash Point:105F (TCC)
Lower Limits:0.90
Extinguishing Media:FOAM,ALCOHOL FOAM,CO*2,DRY CHEMICAL,H*2O FOG
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:IF FLAMMABLE,AVOID EXPOS TO SPARKS,FIRE,HOT
METAL SURFACES.STOP LEAK IF CAN W/O RISK. USE H*2O SPRAY TO REDUCE
VAPORS. TAKE UP W/SAND OR OTHR NON-COMBUSTIBLE ABSORBENT MATL &
PLACE IN CNTNR FOR LATER DISPOSAL;OR DIKE FAR AHEAD OF SPILL
FORLATR DISP
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP FROM HEAT,SPARKS & OPEN FLAME.
USE ADEQUATE VENTILATION. AVOID PROLONGED/REPEATED CONTACT W/SKIN.
DO NOT TAKE INTERNALLY. GROUND & (SEE SUPP DATA
Other Precautions:EFFECTS OF OVEREXP:CHARACTERIZED BY PROGRESSIVE
STEPS-HEADACHE,DIZZINESS,STAGGERING,CONFUSION,& UNCONSCIOUSNESS.
SKIN/EYE CONTACT:PRIMARY IRRITATION. CHRONIC- NOT FULLY
INVESTIGATED
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED SCBA FOR CONCENTRATIONS
ABOVE TLV LIMITS
Ventilation:LOCAL EXHAUST
Other Protective Equipment:EYE BATH & SAFETY SHOWER
Supplemental Safety and Health
& STORING: BOND CONTAINERS WHEN POURING LIQUIDS & POWDERS TO AVOID
STATIC CHARGE BUILDUP. DATE OF PREP: 11/18/85.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:172-390F
Vapor Density:>1
Spec Gravity:1.1614
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:56
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HEAT,SPARKS,OPEN FLAME & FIRE
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY CAUSE CARBON
MONOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE UNDER SAFE CONDITIONS OR DISPOSE OF
IAW LOCAL,STATE, & FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:139 7215;KODAK INDUSTREX DEVELOPER REPLENISHER,PT.A PCD 3606
Kit Part:Y
CAGE:19139
CAGE:19139
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 60-65%
Other REC Limits:NONE RECOMMENDED
Ingred Name:POTASSIUM SULFITE
CAS:10117-38-1
RTECS #:WT3530000
Fraction by Wt: 20-25%
Other REC Limits:NONE RECOMMENDED
Ingred Name:HYDROQUINONE (SARA III)
CAS:123-31-9
RTECS #:MX3500000
Fraction by Wt: 6%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3; 9394
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:POTASSIUM HYDROXIDE (SARA III)
CAS:1310-58-3
RTECS #:TT2100000
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:C, 2 MG/M3
ACGIH TLV:C 2 MG/M3; 9394
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:POTASSIUM CARBONATE
CAS:584-08-7
RTECS #:TS7750000
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES:MAY CAUSE IRRITATION OR
BURNS.SKIN:LOW HAZARD FOR NORMAL SERVICE.MAY CAUSE
IRRITATION.INGEST:MAY BE HARMFUL IF SWALLOWED.INHAL:EXPECTED TO BE
A LOW HAZARD FOR NORMAL SERVICE.MAY CAUSE RESPIRATORY IRRITATION.
Explanation of Carcinogenicity:THERE ARE NO INGREDIENTS ABOVE 0.1%
WHICH ARE IDENTIFIED AS CARCINOGENS BY NTP,IARC OR OSHA.
Effects of Overexposure:EYES:TRANSCIENT IRRITATION.SKIN:ALLERGIC SKIN
REACTIONS.
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING
RESPIRATORY AILMENTS MAY BE AT INCREASED RISK FROM EXPOSURE.
======================= First Aid Measures =======================
First Aid:SKIN:REMOVE CONTAMINATED CLOTHING;WASH WITH SOAP AND
WATER.EYES:FLUSH WITH WATER FOR 15 MINUTES.INHAL:REMOVE TO FRESH
AIR.GIVE OXYGEN OR ARTIFICIAL RESPIRATION IF NEEDED.INGEST:DO NOT
INDUCE VOMITING. GET PROMPT QUALIFIED MEDICAL ATTENTION.IF
CONSCIOUS,DRINK 1-2 GLASSES OF WATER.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:USE MEDIA APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures:USE A SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE EQUIPMENT.COOL FIRE EXPOSED CONTAINERS WITH WATER
FOG.
Unusual Fire/Explosion Hazard:FIRE MAY CAUSE PRODUCTION OF HAZARDOUS
TOXIC FUMES.
================== Accidental Release Measures ==================
Spill Release Procedures:SOAK UP WITH NON-COMBUSTIBLE INERT
ADSORBANT(EG.CLAY);PLACE COLLECTED MATERIEL IN AN APPROPRIATE
CONTAINER FOR DISPOSAL;CLEAN SPILL AREA TO REMOVE
SLIPPERINESS.SMALL SPILLS CAN BE FLUSHED TO SEWER WIT H PLENTY OF
WATER.
Neutralizing Agent:NONE
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS CLOSED.USE WITH
ADEQUATE VENTILATION.
Other Precautions:AVOID BREATHING VAPORS OR MISTS. DO NOT GET IN EYES,
ON SKIN OR ON CLOTHING. WASH THOROUGHLY AFTER HANDLING AND BEFORE
EATING OR DRINKING. REMOVE CONTAMINATED CLOTHING PROMPTLY. KEEP OUT
OF REACH OF C HILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NEEDED IN NORMAL SERVICE.
Ventilation:USE GENERAL DILUTION VENTILATION.MFR RECOMMENDS 10 AIR
CHANGES PER HOUR.
Other Protective Equipment:PROTECTIVE CLOTHING,AS NEEDED.PROVIDE A
LOCAL EYE WASH STATION AND SAFETY SHOWER.
Work Hygienic Practices:WASH HANDS.SEPERATE WORK CLOTHES FROM STREET
CLOTHES.LAUNDER WORK CLOTHES BEFORE REUSE.KEEP FOOD OUT OF THE WORK
AREA.
Supplemental Safety and Health
KEY1:N1
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:>212F,>100C
Vapor Pres:24
Vapor Density:0.6
Spec Gravity:1.31
pH:12.0
Solubility in Water:COMPLETE
Appearance and Odor:LIQUID;OFF-WHITE;ODORLESS
Percent Volatiles by Volume:65
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS,STRONG ACIDS.
Stability Condition to Avoid:HIGH HEAT.
Hazardous Decomposition Products:SULFUR DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL,STATE AND
LOCAL REGULATIONS.
| 1 | gloves_mandatory |
=======================================================
NIIN: 01-350-4743
Product ID: MIL-P-24441 REACTOR COMP B, 5754
Kit Part: Y
Cage: 26351
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 26351
=======================================================
Item Description Information
=======================================================
Item Manager: GSA
Item Name: EPOXY COATING KIT
Specification Number: MIL-P-24441/22
Type/Grade/Class: TY 3 CL A
Unit of Issue: KT
UI Container Qty: 0
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: YES
IARC: YES
OSHA: NO
Effects of Exposure: ACUTE:EYES:IRRITATION MAY OCCUR. SKIN:IRRITATING. MAY
RESULT IN DERMATITIS. MAY CAUSE SENSITIZATION OR OTHER ALLERGIC RESPONSES.
INHALATION:MAY CAUSE IRRITATION. INGESTION:MAY CAUSE GASTRO-INTESTINAL
IRRITATION. CHRONIC:WARNING:THIS PRODUCT CONTAINS A CHEMICAL WHICH IS KNOWN
TO THE STATE OF CALIFORNIA TO CAUSE CANCER.
Explanation Of Carcinogenicity: SEE "LR" VERSION FOR ADDITIONAL INFORMATION
(FP N).
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: SKIN & RESPIRATORY CONDITIONS.
First Aid: EYES:FLUSH IMMED W/COPIOUS QTYS OF WATER FOR AT LEAST 15 MINUTES.
GET MEDICAL ATTENTION IMMEDIATELY. SKIN:REMOVE CONTAMINATED CLOTHING, WASH
SKIN IMMED & THORO W/WATER & THEN W/PLENTY OF SOAP & WATER.
LAUNDER CLOTHES BEFORE REUSE. GET IMMED MED ATTN IF IRRIT OCCURS.
INHAL:REMOVE TO FRESH AIR. GIVE ARTF RESP IF NEEDED. GET MED ATTN.
INGEST:CALL MD IMMED TO DETERMINE WHETHER/NOT TO INDUCE VOMIT.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: REMOVE ALL SOURCES OF IGNITION. AVOID INHALATION OF
VAPORS. VENTILATE AREA. CLEAN UP W/ABSORBENT MATERIALS.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE I/A/W LOCAL, STATE & FEDERAL REGULATIONS.
DO NOT INCINERATE UNOPENED CONTAINERS.
Handling And Storage Precautions: STORE IN BUILDING DESIGNED & PROTECTED
FOR STORAGE OF LIQUIDS W/NPFA CLASS GIVEN BY OSHA.
Other Precautions: AVOID BREATHING DUST OR CHIPS FROM SANDING OR BLASTING
SURFACES COATED W/THIS PRODUCT. RECOMMEND GROUNDING & BONDING OF
CONTAINERS WHEN TRANSFERRING LIQUIDS & POWDERS TO AVOID STATIC CHARGE
BUILD UP.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: SCC
Flash Point Text: 115F,46C
Extinguishing Media: FOAM, CO*2, DRY CHEMICAL.
Fire Fighting Procedures: USE NIOSH APPRVD SCBA & FULL PROT EQUIP (FP N).
SMOTHER FLAMES W/ONE OF ABOVE EXTING MEDIA. WATER MAY BE USED TO COOL
UNOPENED CNTNRS, BUT MUST NOT BE (SUPDAT)
Unusual Fire/Explosion Hazard: COMBUSTIBLE, CLASS II. CONTAINERS MAY EXPLODE
WHEN EXPOSED TO EXTREME HEAT.
=======================================================
Control Measures
=======================================================
Respiratory Protection: IN OUTDOOR/OPEN AREAS, W/UNRESTRICTED VENT, USE A NIOSH
APPRVD FILTER RESP TO REMOVE SOLID AIR-BORNE PARTICLES OF OVERSPRAY DURING
SPRAY APPLICATION. IN RESTRICTED VENT AREAS, USE A NIOSH APPRVD RESPI/A/W
29 CFR 1910.134 TO REMOVE (SUPDAT)
Ventilation: PROVIDE SUFFICIENT VENT, IN VOL & PATTERN, TO KEEP TLV &
LEL OF HAZ INGS BELOW LIMS SPECIFIED & TO REMOVE DECOMP
Other Protective Equipment: ANSI APPROVED EYE WASH FOUNTAIN & DELUGE SHOWER (FP
N). WEAR APPROP IMPERVIOUS PROT CLOTHING TO PREVENT SKIN CONTACT.
Work Hygienic Practices: REMOVE & WASH SOILED CLOTHING BEFORE REUSE, WASH HANDS
BEFORE EATING OR SMOKING.
Supplemental Safety and Health: NOTE:USERS OF "L" VERSION SHOULD CONSULT "LR"
VERSION FOR ADDNL INFO (FP N). FIRE FIGHT PROC:USED AS EXTING MEDIA. TAKE
CARE TO PVNT SPREAD OF BURNING LIQ W/WATER. CLSD CNTNRS MAY EXPLODE WHEN
EXPOS TO EXTREME HEAT. RESP PROT:COMBINATION OF PARTICULATES & VAPS.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: 308F,153C
Vapor Pres: SEE ING 2
Vapor Density: HVR/AIR
Spec Gravity: 1.27 (FP N)
Evaporation Rate & Reference: SLOWER THAN ETHER
Appearance and Odor: NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume: 20(WT)
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products: CO, CO*2, VARIOUS HYDROCARBON FRAGMENTS,
ALDEHYDES.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
Transportation Information
=======================================================
Trans ID NO: 128155
Product ID: MIL-P-24441 REACTOR COMP B, 5754
Review Date: 04/21/1998
Multiple KIT Number: 0
Kit Part IND: Y
Review IND: Y
Unit Of Issue: KT
Container QTY: 0
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: DNL
DOT Proper Shipping Name: COATING SOLUTION
DOT PSN Modifier: (INCLUDES SURFACE TREATMENTS OR COATINGS USED FOR INDUSTRIAL
OR OTHER PURPOSES SUCH AS VEHICLE UNDERCOATING, DRUM OR BARREL LINING)
Hazard Class: 3
UN ID Num: UN1139
DOT Packaging Group: III
Label: 3
Special Provision: B1,T7,T30
Packaging Exception: 150
Non Bulk Pack: 203
Bulk Pack: 242
Max Qty Pass: 60 L
Max Qty Cargo: 220 L
Vessel Stow Req: A
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: ENF
IMO Proper Shipping Name: COATING SOLUTION o
IMO PSN Modifier: (INCLUDES SURFACE TREATMENTS OR COATINGS USED FOR INDUSTRIAL
PURPOSES SUCH AS VEHICLE UNDER-COATING, DRUM OR BARREL LINING)
IMDG Page Number: 3321
UN Number: 1139
UN Hazard Class: 3.3
IMO Packaging Group: III
Subsidiary Risk Label: -
EMS Number: 3-05
MED First Aid Guide NUM: 310
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: GZN
IATA UN ID Num: 1139
IATA Proper Shipping Name: COATING SOLUTION +
IATA PSN Modifier: (INCLUDES SURFACE TREATMENTS OR COATINGS USED FOR INDUSTRIAL
OR OTHER PURPOSES SUCH AS VEHICLE UNDERCOATING, DRUM OR BARREL LINING)
IATA UN Class: 3
IATA Label: FLAMMABLE LIQUID
UN Packing Group: III
Packing Note Passenger: 309
Max Quant Pass: 60L
Max Quant Cargo: 220L
Packaging Note Cargo: 310
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: GZN
AFI Proper Shipping Name: COATING SOLUTION
AFI Hazard Class: 3
AFI UN ID NUM: UN1139
AFI Packing Group: III
Special Provisions: P5
Back Pack Reference: A7.3
=======================================================
HAZCOM Label
=======================================================
Product ID: MIL-P-24441 REACTOR COMP B, 5754
Cage: 26351
Company Name: INTERNATIONAL PAINT INC
Street: 6001 ANTOINE DR
Zipcode: 77091
Label Required IND: Y
Date Of Label Review: 03/24/1998
Status Code: C
Label Date: 03/24/1998
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: Moderate
Reactivity Hazard: None
Hazard And Precautions: COMBUSTIBLE. ACUTE:EYES:IRRITATION MAY OCCUR.
SKIN:IRRITATING. MAY RESULT IN DERMATITIS. INHALATION:MAY CAUSE IRRITATION.
INGESTION:MAY CAUSE GASTRO-INTESTINAL IRRITATION. CHRONIC:CANCER HAZARD.
CONTA INS MATERIAL WHICH IS LISTED AS A HUMANRESPIRATORY CARCINOGEN (FP N).
MAY CAUSE SENSITIZATION OR OTHER ALLERGIC RESPONSES.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:P/N 6AT6 ELECTRON VACUUM TUBE
CAGE:33173
CAGE:33173
============= Composition/Information on Ingredients =============
Ingred Name:RHENIUM 187
Fraction by Wt: 2%
Other REC Limits:NONE RECOMMENDED
Ingred Name:RHENIUM
Fraction by Wt: <98%
Other REC Limits:NONE RECOMMENDED
Ingred Name:TUNGSTEN,AS W,SOLUBLE COMPOUNDS.
CAS:7440-33-7
RTECS #:YO7175000
Fraction by Wt: <98%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOE ESTABLISHED
ACGIH TLV:1 MG/M3/3 STEL; 9596
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ELECTRON TUBES OPERATE UNDER AT
TEMPERATURES THAT CAN PRODUCE BURNS TO SKIN IF CONTACT IS MADE.
Explanation of Carcinogenicity:NONE SPECIFIED BY MANUFACTURER.
Effects of Overexposure:BURNS TO SKIN ON CONTACT.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:NO EMERGENCY CARE ANTICIPATED.
===================== Fire Fighting Measures =====================
Extinguishing Media:MATERIAL IS NON-FLAMMABLE.
Fire Fighting Procedures:NONE.
Unusual Fire/Explosion Hazard:ELECTRON TUBES OPERATE UNDER HIGH VACUUM
& IMPLOSION COULD OCCUR UNDER HIGH TEMPERATURES DURING FIRES OR
DURING DISPOSAL PROCEDURES.
================== Accidental Release Measures ==================
Spill Release Procedures:NONE
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE
Ventilation:NONE
Other Protective Equipment:NONE
Work Hygienic Practices:NONE
Supplemental Safety and Health
ITEM IS AN ARTICLE AND DOES NOT REQUIRE AN MSDS IAW 29 CFR 1910.1200.
================== Physical/Chemical Properties ==================
HCC:A2
Appearance and Odor:GLASS TUBE; ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:183A111 SEVEN STAR FLAT LATEX WALL PAINT
CAGE:ACEHA
CAGE:ACEHA
============= Composition/Information on Ingredients =============
Ingred Name:BARIUM, CALCIUM, MAGNESIUM, STRONTIUM, ALUMINUM SILICATE
FLUX; (ALUMINUM SILICATE)
CAS:66402-68-4
Fraction by Wt: 13.3%
OSHA PEL:5 MG/CUM (MFR)
ACGIH TLV:5 MG/CUM (MFR)
Ingred Name:NEPHELINE SYENITE
CAS:37244-96-5
Fraction by Wt: 3.1%
OSHA PEL:N/K
ACGIH TLV:5 MG/CUM (MFR)
Ingred Name:1-PROPANOL, 2-AMINO-2-METHYL-;
(2-AMINO-2-METHYL-1-PROPANOL)
CAS:124-68-5
RTECS #:UA5950000
Fraction by Wt: 0.2%
OSHA PEL:20 PPM (MFR)
ACGIH TLV:10 PPM (MFR)
Ingred Name:AMMONIA (SARA 302/313) (CERCLA)
CAS:7664-41-7
RTECS #:BO0875000
Fraction by Wt: <0.1%
OSHA PEL:50 PPM
ACGIH TLV:25 PPM/35 STEL
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:CALCIUM CARBONATE
CAS:1317-65-3
RTECS #:EV9580000
Fraction by Wt: 22.5%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 17.9%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:IN A CONFINED AREA VAPORS IN
HIGH CONCNETRATION ARE ANESTHETIC, IRRITANT TO UPPER RESPIRATORY
SYSTEM. SIGNS AND SYMPTOMS OF EXPOSURE:LIGHTHEADEDNESS AND
STAGGERED GAIT. CHRONIC:PROBLEMS WITH RES PIRATORY SYSTEM MAY BE
AGGRAVATED BY EXPOSURE TO VAPORS.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:CHRONIC PROBLEMS WITH RESPIRATORY
SYSTEM MAY BE AGGRAVATED TO EXPOSURE TO VAPORS.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD IMMEDIATELY . INHAL:REMOVE FROM EXPOSURE.
RESTORE BREATHING. KEEP WARM AND QUIET. SKIN:WASH WITH SOAP AND
WATER. EYES:FLUSH WITH WATER FOR @ LEAST 15 MINUTES. GET MEDICAL
AID. LAU NDER CONTAMINATED CLOTHING BEFORE REUSE.
===================== Fire Fighting Measures =====================
Flash Point:199F,93C
Extinguishing Media:NON-COMBUSTIBLE. FOR DRY SOLIDS USE WATER, FOAM
CO*2, DRY CHEMICALS.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . WATER MAY BE USED TO COOL CLOSED CONTAINERS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS EXPOSED TO EXTREME HEAT
MAY RUPTURE DUE TO PRESSURE BUILD-UP. CONTENTS MAY SPATTER IF
TEMPERATURE EXCEEDS 212F.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DOL STORAGE CATEGORY 3B.
Other Precautions:KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL EXHAUST:PREFERABLE. MECHANICAL (GENERAL):ACCEPTABLE.
Other Protective Equipment:ANSI APPRVD EMERGENCY EYE WASH & DELUGE
SHOWER .
Work Hygienic Practices:AVOID BREATHING VAPOR OR SPRAY MIST. AVOID
CONTACT WITH SKIN OR EYES.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Vapor Density:HVR/AIR
Spec Gravity:1.35 (H*2O=1)
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:INSOLUBLE
Appearance and Odor:COLORED PIGMENTED LIQUID WITH SLIGHT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NO HAZARDOUS REACTIONS ARE EXPECTED UNDER NORMAL USE.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON DIOXIDE AND CARBON MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE IN APPROVED FACILITY. DO NOT
INCINERATE CLOSED CONTAINERS. DISPOSE OF IN ACCORDANCE WITH
FEDERAL, STATE AND LOCAL REGULATIONS REGARDING POLLUTION.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:FP-1540, PANASONIC DEVELOPER FQ-Z120-P (SUP
CAGE:S0293
CAGE:S0293
============= Composition/Information on Ingredients =============
Ingred Name:IRON (III) OXIDE; (FERRITE) (ALT MFR CAS NOS:1317-38-0,
1314-13-2, 1309-48-4)
CAS:1309-37-1
RTECS #:NO7400000
Fraction by Wt: 80%
OSHA PEL:10 MG/M3 (FE)
ACGIH TLV:5 MG/M3(FE),B2; 9293
Ingred Name:TONER; (FQ-T50K-P)
Fraction by Wt: 20%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:HEALTH HAZARD IS MINIMAL BEING NEITHER
IRRITATING, CORROSIVE, VOLATILE NOR TOXIC. MUTAGENICITY IS
NEGATIVE. CONTACT W/EYES MAY RESULT IN MECHANICAL IRRITATION.
INHALATION OF DUST MAY IRRITATE MUCOUS M EMBRANES. INGESTION MAY
RESULT IN GASTRIC DISTURBANCES. TLV OF PROD REC BY MFR:8 MG/M3
TDUST;2 RESP.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES:IMMED WASH W/RUNNING WATER FOR AT LST 15 MINUTES. IF
IRRIT DEVELOPS, GET MD. SKIN:WASH AFFECTED AREAS W/SOAP & WATER. IF
IRRIT DEVELOPS, GET MD. REMOVE & LAUNDER CONTAM CLTHG BEFORE REUSE.
INGEST :IF SWALLOWED DILUTE W/WATER & IMMED INDUCE VOMIT. GET MD IF
VICTIM IS UNCONSCIOUS OR HAVING CONVULSIONS. INHAL:REMOVE TO FRESH
AIR AREA. AID IN BRTHG IF NECESSARY & GET MD.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER, CO*2, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . NOT FLAMMABLE OR COMBUSTIBLE BUT WILL BURN
IF IGNITED.
Unusual Fire/Explosion Hazard:NONE UNDER NORMAL STORAGE AND USE
CONDITIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:VACUUM OR SWEEP UP DRY POWDER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID DUST INHALATION AND SKIN
CONTACT.
Other Precautions:KEEP CONTAINERS CLOSED. STORE IN A COOL, DRY PLACE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED UNDER NORMAL USE. USE NIOSH/MSHA
APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:NONE REQUIRED UNDER NORMAL USE.
Other Protective Equipment:NONE REQUIRED UNDER NORMAL USE.
Work Hygienic Practices:MINIMIZE BREATHING DUST.
Supplemental Safety and Health
MFR'S TRADE NAME/PART NO:MAGNEFINE DEVELOPER.
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:4.2 (H*2O=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:FINE BLACK POWDER, PRACTICALLY ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:ABNORMALLY HIGH TEMPERATURE.
Hazardous Decomposition Products:NONE IN NORMAL HANDLING AND USE.
Conditions to Avoid Polymerization:ABNORMALLY HIGH TEMPERATURE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE I/A/W LOCAL, STATE & FEDERAL
REGULATIONS.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:SOLUTION S0191 EX-1
Preparer's Name:JOHN J. KASPER
CAGE:89524
CAGE:89524
============= Composition/Information on Ingredients =============
Ingred Name:HYDROCHLORIC ACID; (HYDROGEN CHLORIDE)
CAS:7647-01-0
RTECS #:MW4025000
Fraction by Wt: 20-40%
OSHA PEL:5 PPM, C
ACGIH TLV:5 PPM, C
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:WASTE DISP METH:WHICH HAS PH CNTRL SYS IN OPER.EMPTY PROD
CNTNRS SHD BE PUNCTURED,IF PLASTIC,& PLACED IN GARBAGE (ING 3)
RTECS #:9999999ZZ
Ingred Name:ING 2: COLLECTION CONTAINER.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50: (ORAL,RAT) 900 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: CORROSIVE TO EYES WITH POSSIBLE
PERMANENT DAMAGE DEPENDING ON LENGTH OF EXPOSURE AND ON FIRST AID
ACTION GIVEN. SKIN: CORROSIVE TO SKIN, POSSIBLY RESULTING IN THIRD
DEGREE BURNS DEPENDING ON LENG TH OF EXPOSURE AND ON FIRST AID
ACTION GIVEN. INGESTION: CAN BE HARMFUL. INHALATION: CAN BE
CORROSIVE (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: TO MUCOUS MEMBRANES AND LUNGS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: IMMED FLUSH FOR AT LEAST 15 MIN WHILE HOLDING EYELIDS
OPEN. CALL PHYS AT ONCE. SKIN: IMMED FLUSH W/H*2O FOR AT LEAST 15
MIN. FOR LRG SPLASH, FLOOD BODY UNDER SHOWER. CALL PHYS AT ONCE.
INGEST: D O NOT INDUCE VOMIT. GIVE H*2O. CALL PHYS. INHAL: REMOVE
TO FRESH AIR. TREAT SYMP. CALL PHYS. CAUTION: IF UNCON, HAVING
TROUBLE BRTHG/IN CONVULSIONS, DO NOT INDUCE VOMIT/GIVE H*2O. NOTE
TO (SUPP DATA)
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE CONDITIONS .
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:ACID REACTS WITH MOST METALS TO RELEASE
HYDROGEN GAS, WHICH CAN FORM EXPLOSIVE MIXTURES WITH AIR.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL LIQ SPILLS: COVER SPILL W/SODIUM
BICARBONATE/SODA ASH/LIME MIX. MIX & ADD H*2O TO FORM SLURRY. FLUSH
DOWN DRAIN WITH LARGE AMOUNTS OF WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:WARNING: CAUSES BURNS TO SKIN AND
EYES. DO NOT GET IN EYES, ON SKIN, OR ON CLOTHING. AVOID BREATHING
VAPORS. DO NOT TAKE INTERNALLY.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESPIRATORY PROTECTION IS NOT NORMALLY NEEDED.
USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF
CONCERN .
Ventilation:GEN VENT IS RECOM. ADDITIONALLY, LOCAL EXHAUST VENTILATION
IS RECOMMENDED WHERE VAPORS, MISTS OR AEROSOLS MAY BE RELSD.
Other Protective Equipment:THE AVAILABILITY OF AN EYE WASH FOUNTAIN AND
SAFETY SHOWER IS RECOMMENDED.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
MATLS TO AVOID: HYDROXIDE (LIME), CYANIDES, SULFIDES, HYPOCHLORITES,
CHLORITES) WHICH CAN GENERATE HEAT W/SPLATTERING/BOILING & RELS OF
TOX FUMES. FIRST AID PROC: PHYS: PROBABLE MUCOSAL DMG MAY CONTRA
INDICATE USE OF GASTRIC LAVAGE. MEASURES AGAINST CIRCULATORY SHOCK,
RESP DEPRESSION & CONVULSIONS MAY BE NEEDED.
================== Physical/Chemical Properties ==================
HCC:C1
pH:<1
Solubility in Water:COMPLETELY
Appearance and Odor:COLORLESS LIQUID, SHARP ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALKALINE MATLS (EG.AMMONIA & ITS SOLNS, CARBONATES, SODIUM HYDROXIDE
(CAUSTIC),POTASSIUM HYDROXIDE, CALCIUM (SUPP DATA)
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:HCL
==================== Disposal Considerations ====================
Waste Disposal Methods:IF PROD BECOMES WASTE, IT MEETS CRITERIA OF HAZ
WASTE AS DEFINED UNDER RCRA 40 CFR 261. HAZ WASTE D002. ACID SOLNS
SHD BE NEUT BEFORE BEING DISCHARGED TO SANITARY SEWER.
ALTERNATIVELY, AN ACID SOLN MA Y BE DISP INTO WASTE TREATMENT PLANT
(INGRED 2)
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CALCIUM OXIDE
CAGE:DO870
CAGE:60777
CAGE:DO870
CAGE:70829
============= Composition/Information on Ingredients =============
Ingred Name:CALCIUM OXIDE
CAS:1305-78-8
RTECS #:EW3100000
Fraction by Wt: 99-100%
OSHA PEL:5 MG/M3
ACGIH TLV:2 MG/M3; 9192
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE-IRRITATION TO UPPER RESPIRATORY
PASSAGES. CHEMICAL BURNS OR SEVERE IRRITATION TO EYES, NOSE, MOIST
SKIN. HARMFUL IF SWOLLOWED, MAY CAUSE BURNS TO MOUTH AND STOMACH.
TARGET ORGANS:RESPIRATORY SYS TEM, LUNGS, KIDNEYS, AND BLOOD.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SKIN: BURNS OR IRRITATION ESPECIALLY TO
PERSPIRING PERSON. EXCESS COUGHING DUE TO IRRITATION TO UPPER
RESPIRATORY SYSTEM. VOMITING, STOMACHACHE, DIARRHEA.
Medical Cond Aggravated by Exposure:BRONCHITIS OR PNEUMONIA. EYES AND
"OPEN CUTS" ARE PARTICULARLY VULNERABLE.
======================= First Aid Measures =======================
First Aid:SKIN:WASH OFF ALL LIME DUST WITH EXCESS WATER. APPLY CREAM OR
OINTMENT. EYE:FLUSH IMMEDIATELY W/ LG AMTS OF WATER FOR AT LEAST 15
MIN & SEE MEDICAL DOCTOR IMMEDIATELY. INHAL:REMOVE TO, IF NOT
BREATHIN G GIVE CPR/OXYGEN. INGEST:DRINK LARGE AMOUNTS OF WATER,
ORANGE JUICE, FOLLOWED BY EGG WHITE IN WATER. CALL PHYSICIAN
IMMEDIATELY.
===================== Fire Fighting Measures =====================
Extinguishing Media:NON-COMBUSTIBLE. USE MEDIA SUITABLE FOR SURROUNDING
FIRES.
Fire Fighting Procedures:NONE IDENTIFIED.
Unusual Fire/Explosion Hazard:CONTACT WITH MOISTURE OR WATER MAY
GENERATE SUFFICIENT HEAT TO IGNITE COMBUSTIBLES.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR SELF CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING. VENTILATE AREA. SHOVEL MATERIAL INTO DRY
CONTAINERS. FLUSH RESIDUE WITH WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A DRY PLACE. AVOID ANY TYPE
OF MOISTURE. KEEP CONTAAINER CLOSED.
Other Precautions:AVOID CONTACT. DO NOT GENERATE DUST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IN DUSTY LOCATIONS, USE NIOSH/MSHA APPROVED
RESPIRATORS.
Ventilation:APPLY ADEQUATE VENTILATION TO KEEP DUST BELOW TLV. VENT
DUST TO "COLLECTOR".
Other Protective Equipment:LONG SLEEVED SHIRT W/BUTTON COLLAR & LONG
PANTS EXTENDING OVER HIGH TOP WORK BOOTS.EMERG EYE WASH AND DELUGE
SHOWER.
Work Hygienic Practices:WASH WELL WITH WATER UPON COMPLETION OF SHIFT.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:B3
Boiling Pt:B.P. Text:5162F,2850C
Spec Gravity:3.34
Solubility in Water:NEGLIGIBLE, <0.1%
Appearance and Odor:WHITE OR GREY SOLID, ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:NO
WATER AND ACIDS.
Stability Condition to Avoid:MOISTURE AND WATER.
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF I/A/W FEDERAL, STATE AND LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:FLAW-FINDER AG-2A-FW PENETRANT
Preparer's Name:GEORGE KOSEL,CHIEF CHEM
CAGE:03530
CAGE:03530
============= Composition/Information on Ingredients =============
Ingred Name:"NOT HAZARDOUS"(MANUFACTURER STATED IN MSDS THAT ITEM
CONTAINS NO HAZARDOUS INGREDIENTS ACCORDING TO 29CFR1910.2000;HCR
Fraction by Wt: 100%
Other REC Limits:NOT STATED IN MSDS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE ESTABLISHED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: CAUSES IRRITATION OF EYES, AND
SKIN; INGESTION MAY CAUSE NAUSEA, VOMITING,ETC..
Effects of Overexposure:INHALATION: NO EVIDENCE OF ADVERSE EFFECTS FROM
AVAILABLE INFORMATIO. SKIN: MAY CAUSE TEMPORARY REDDENING OR SLIGHT
IRRITATION. EYES: CAUSES IRRITATION WITH POSSIBLE MODERATE CORNEAL
INJURY. INGESTION : SLIGHT TOXIC! MAY CAUSE NAUSEA, AND/OR
VOMITING.
Medical Cond Aggravated by Exposure:NONE CURRENTLY KNOWN.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR; SKIN AND EYES: FLUSH WITH
PLENTY OF WATER FOR ABOUT 15 MINUTES.SEEK MEDICAL HELP IF
IRRITATION PERSISTS; INGESTION: DRINK TWO (2) GLASSES OF WATER AND
INDUCE VOMITING. CALL A PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:383F, 195C
Extinguishing Media:USE CARBON DIOXIDE, DRY CHEMICAL MEDIA FOR SMALL
FIRES. APPLY ALCOHOAL TYPE OR ALL-PURPOSE-TYPE FOAMS FOR LARGE
FIRES.
Fire Fighting Procedures:DO NOT DIRECT A SOLID STREAM OF WATER OR FOAM
INTO HOT, BURNING POOLS; THIS MAY CAUSE FROTHING.THIS MATERIAL MAY
CAUSE A FLOATING FIRE HAZARD. USE SCBA.
Unusual Fire/Explosion Hazard:CONTAINERS MAY BURSTAND/OR EXPLODE IN
HEAT OF FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION; RECOVER FREE
LIQUID; USE SUITABLE INERT ABSORBENT SUCH AS SAND, CLAY, ETC..TO
ABSORB LIQUID. THIS MATERIAL IS HIGHLY TOXIC TO FISH. AVOID
DISCHARGE TO NATURAL WATERS. A VOID DRAINAGE OF LARGE SPILLS TO
SEWERS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE. KEEP
CONTAINERS CLOSED AND PLAINLY LABELED.
Other Precautions:DO NOT PRESSURIZE, CUT, WELD, BRAZE, SOLDER, DRILL,
GRIND, OR EXPOSE SUCH CONTAINERS TO HEAT, FLAME, SPARKS OR OTHER
SOURCES OF IGNITION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED SELF-CONTAINED BREATHING
APPARATUS IF NEEDED.
Ventilation:GENRAL VENTILATION IS SUFFICIENT.
Other Protective Equipment:USE CHEMICAL RESISTANT APRON OR OTHER
IMPERVIOUS CLOTHING,IF NEEDED,TO AVOID CONTAMINATING REGULAR
CLOTHING.EYE-WASH FAC
Supplemental Safety and Health
NSN IS FOR PENETRANTS OF TYPE I, METHOD C, LEVEL 2 OF
MIL-I-25135,REV:E. PER QPL-25135-15, TWO PENETRANTS AG-2-FS, AND
AG-2A-FW FROM AMERICAN GAS CHEMICAL COMPANY QUALIFY FOR TYPE I,
METHOD C, LEVEL 2 . THIS ENTRY IS OF AG-2A-FW PENETRANT. SEE PNIND
-'B' FOR AG-2-FS PENETRANT.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:>482F,>250C
Decomp Temp:Decomp Text:>482F/>250C
Vapor Pres:0.01 MMHG
Vapor Density:>1.0(AIR=1
Spec Gravity:0.98
Evaporation Rate & Reference:<0.01 (N-BU-ACETATE=1)
Solubility in Water:COMPLETE
Appearance and Odor:YELLO-GREEN LIQUID; MILD CHARACTERISTIC ODOR.
Percent Volatiles by Volume:>95%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENT.
Stability Condition to Avoid:EXTREME HEAT
Hazardous Decomposition Products:BURNING CAN PRODUCE CARBON DIOXIDE
AND/OR CARBON MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE IN A FURNACE WHERE PERMITTED UNDER
APPROPRIATE LOCAL,STATE AND FEDERAL REGULATIONS.AT VERY LOW
CONCENTRAIONS(LESS THAN 10 PPM),THIS PRODUCT CAN BE BIODEGRADED IN
A BIOLOGICAL WASTEWATER TRE ATMENT PLANT;AT HI-CONC.,IT CAUSES
FOAMING PROBLM.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:9040 HURRISAFE SPECIAL FORMULA
Preparer's Name:BOBBIE PETTIT
CAGE:0ZCB7
CAGE:0ZCB7
============= Composition/Information on Ingredients =============
Ingred Name:2-BUTOXYETHANOL (NON HAZ.) (LD50 SKIN RABBITS=200MG/KG)
(LD50 ORAL RAT=470 MG/KG) (LC50 INHALATION RATS=700PPM IN 7 HRS)
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: 10%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:25 PPM
ACGIH TLV:120 MG/M3
Ingred Name:SODIUM METASILICATE
CAS:6834-92-0
Fraction by Wt: 6%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM XYLENESULFONATE
CAS:1300-72-7
Fraction by Wt: 10%
Other REC Limits:NONE RECOMMENDED
Ingred Name:TRISODIUM PHOSPHATE (NON HAZ.)
CAS:7601-54-9
RTECS #:TC9490000
Fraction by Wt: 6%
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TRITON X-100 (SURFACTANT) (NON HAZ.)
Fraction by Wt: 10%
Other REC Limits:NONE RECOMMENDED
Ingred Name:WATER (NON HAZ.)
Fraction by Wt: 58%
Other REC Limits:NONE RECOMMENDED
Ingred Name:VOLATILE ORGANIC COMPOUNDS: (CONCENTRATE) 206 G/L, (4:1
DILUTION) 23 G/L, (LBS/GAL=SCAQMD)
RTECS #:9999999VO
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:THIS IS A RELATIVELY INNOCUOUS
SUBSTANCE NOT EXPECTED TO CAUSE HARM. SHOULD TREATMENT EVER BE
REQUIRED, IT WOULD BE DIRECTED AT CONTROL OF SYMPTOMS.
Medical Cond Aggravated by Exposure:NONE
======================= First Aid Measures =======================
First Aid:SKIN: WASH W/SOAP & WATER. APPLY LOTION. EYES: FLUSH W/WATER
15 MINUTES. OBTAIN ATTENTION IF IRRITATION PERSISTS. INGESTION:
DRINK WARM WATER TO DILUTE STOMACH CONTENTS, DO NOT INDUCE
VOMITING.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:NONE
Autoignition Temp:Autoignition Temp Text:NKNK
Lower Limits:NONE
Upper Limits:NONE
Extinguishing Media:NO FIRE HAZARD.
Fire Fighting Procedures:NA
Unusual Fire/Explosion Hazard:NA
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL: FLUSH W/WATER. LARGE: ABSORB W/SAWDUST,
SAND OR EARTH.
Neutralizing Agent:NA
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY AREA. PREVENT
FREEZING. IF FROZEN, ALLOW TO THAW, STIR WELL A& REUSE. PH4:1
DILUTION 11.4.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE
Ventilation:LOCAL EXHAUST IS SUFFICIENT
Other Protective Equipment:PLASTIC OR RUBBER APRON IF EXCESSIVE
SPLASHING IS EXPECTED. IF CLOTHING BECOMES SOAKED, REMOVE, SHOWER &
WASH CLOTHING.
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Melt/Freeze Pt:M.P/F.P Text:32.0F,0.0C
Decomp Temp:Decomp Text:NA
Vapor Pres:14.2
Vapor Density:0.62
Spec Gravity:1.02
pH:1.4 C
Evaporation Rate & Reference:(BUAC=1) >1 @ 20C
Solubility in Water:100%
Appearance and Odor:BLUE W/VERY MILD ODOR
Percent Volatiles by Volume:94.3
Corrosion Rate:NA
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIALS.
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:MAY BE DISPOSED IN SEWER SYSTEM AFTER CONSULTING
FEDERAL, STATE, LOCAL, COUNTY REGULATIONS FOR APPLICABLE LAWS
PERTAINING TO YOUR AREA.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:HTNN
Preparer's Name:PAUL SAYLOR
CAGE:94481
CAGE:94481
============= Composition/Information on Ingredients =============
Ingred Name:MINERAL OIL; (SOLVENT REFINED PARAFFINIC OIL)
CAS:8012-95-1
RTECS #:PY8030000
Fraction by Wt: 100%
OSHA PEL:5 MG/M3 OIL MIST
ACGIH TLV:5 MG/M3 OIL MIST
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYE/SKIN:BELIEVED TO BE
MINIMALLY IRRITATING.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
======================= First Aid Measures =======================
First Aid:EYES:AS WITH MOST FOREIGN MATERIAL, SHOULD EYE CONTACT OCCUR,
FLUSH WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES. INGEST:CALL MD
IMMEDIATELY . SKIN:FLUSH WITH COPIOUS AMOUNTS OF WATER. CALL MD (
). INHAL:REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O2/ARTIFICIAL
RESPIRATION) .
===================== Fire Fighting Measures =====================
Flash Point:>365F,>185C
Extinguishing Media:DRY CHEMICAL TYPE PREFERRED.
Fire Fighting Procedures:NONE, AVOID USE OF WATER EXCEPT AS FOG TO COOL
EXPOSED EQUIPMENT AND CONTAINERS. USE NIOSH/MSHA APPROVED SCBA AND
FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN SPILL. WIPE UP OR ABSORB ON SUITABLE
MATERIAL AND SHOVEL UP.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATORY EQUIPMENT
REQUIRED IF EXPOSURE LIMITS EXCEEDED.
Ventilation:LOCAL EXHAUST AS REQUIRED IF MIST IS BEING GENERATED.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:V6
Boiling Pt:B.P. Text:WIDE RANGE
Spec Gravity:0.85-0.89
Solubility in Water:INSOLUBLE
Appearance and Odor:AMBER TO DARK LIQUID WITH A SLIGHT ODOR.
Percent Volatiles by Volume:NEGLIG
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Hazardous Decomposition Products:CO, CO2, ALDEHYDES AND KETONES,
COMBUSTION PRODUCTS OF NITROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE. DISPOSAL MUST BE IN ACCORDANCE WITH
LOCAL, STATE AND FEDERAL REGULATIONS GOVERNING DISPOSAL OF OILY
WASTES.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:WEST SYSTEMS 404 HIGH-DENSITY FILLER, 404
Preparer's Name:T.J. ATKINSON
CAGE:75147
CAGE:75147
CAGE:7S147
============= Composition/Information on Ingredients =============
Ingred Name:SULFURIC ACID, CALCIUM SALT (1:1); (CALCIUM SULFATE)
CAS:7778-18-9
RTECS #:WS6920000
Fraction by Wt: >75%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:SILICON DIOXIDE (AMORPHOUS); (TREATED FUMED SILICA)
CAS:67762-90-7
Fraction by Wt: <25%
OSHA PEL:6 MG/M3
ACGIH TLV:10 MG/M3
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION: IF EXPOSURE LIMITS
ARE EXCEEDED, THE RESPIRATORY TRACT MAY BECOME IRRITATED. MAY CAUSE
SHORTNESS OF BREATH, COUGHING AND/OR CHEST TIGHTNESS DUE TO
TEMPORARILY PHYSICALLY OVERLOADINGLUNGS. SKIN CONTACT: MAY CAUSE
IRRITATION AND DRYNESS OF EXPOSED SKIN. EYE CONTACT: MAY CAUSE
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: IRRITATION, REDNESS AND TEARING.
INGESTION: MAY CAUSE GI TRACT IRRITATION. MATERIAL HARDENS WHEN
WETTED; IF INGESTED MAY RESULT IN AN OBSTRUCTION. CHRONIC:
INHALATION: MAY AGGRAVATE EXISTINGRESPIRATORY CONDITIONS. SKIN:
REPEATEDEXPOSURE MAY CAUSE DERMATITIS DUE TO DRYING OF SKIN.
Medical Cond Aggravated by Exposure:SKIN AND RESPIRATORY CONDITIONS
SUCH AS DERMATITITIS AND ASTHMA.
======================= First Aid Measures =======================
First Aid:INGEST: CALL MD IMMEDIATELY . EYES: FLUSH ADEQUATELY WITH
WATER TO REMOVE PARTICLES. IF DISCOMFORT PERSISTS, SEEK MEDICAL
ADVICE. SKIN: WASH WITH SOAP AND WATER. APPLY MOISTURIZING CREAM TO
REPL ENISH MOISTURE IN SKIN IF NECESSARY. INHAL: REMOVE TO FRESH
AIR IF EFFECTS OCCUR. IF EFFECTS PERSIST, SEEK MEDICAL ADVICE.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:NOT COMBUSTIBLE. MEDIA SUITABLE FOR SURROUNDING
FIRE .
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP AND SHOVEL OR USE PROPERLY GROUNDED
VACUUM EQUIPMENT. DO SO IN A MANNER THAT MINIMIZES AIRBORNE DUST.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A DRY AREA. STORAGE
TEMPERATURE (MIN/MAX): 40F(4C)/100F(38C). SHELF LIFE: THREE YEARS
OR LONGER IF STORED PROPERLY.
Other Precautions:AVOID HANDLING THAT WILL UNNECESSARILY GENERATE
AIRBORNE DUST. PROPERLY GROUND ALL MATERIAL HANDLING EQUIPMENT TO
PREVENT STATIC DISCHARGE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WORK ENVIRONMENTS SHOULD BE MAINTAINED BELOW
APPLIC EXPOSURE LEVEL THROUGH USE OF ENGINEERING CONTROLS SUCH AS
DILUTION & EXHAUST VENTILATION. IF THIS IS NOT FEASIBLE, USE NIOSH
APPROVED DUST MASK/RES PIRATOR FOR NUISANCE DUST (TC-21C).
Ventilation:MAINTAIN WORK ENVIRONMENTS BELOW APPLIC EXPOS LEVEL THRU
USE OF ENGINEERING CONTROLS SUCH AS DILUTION & EXHAUST VENT.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
AREAS EXPECTED TO HAVE REPEATED EXPOS, SUCH AS HANDS, MAY NEED
(SUPDAT)
Work Hygienic Practices:PRACTICE GOOD INDUSTRIAL HYGIENE BY WASHING
W/SOAP & WATER AFTER EACH USE. APPLY MOISTURIZING CREAM TO (SUPDAT)
Supplemental Safety and Health
OTHER PROT EQUIP: TO BE PROTECTED BY AN IMPERVIOUS MATERIAL TO PREVENT
DRYNESS. BARRIER CREAMS CAN BE USED EFFECTIVELY. HYGIENE PRACT:
REPLENISH MOISTURE IF NECESSARY.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:2642F,1450C
Spec Gravity:2.45-2.96
Solubility in Water:0.26%
Appearance and Odor:OFF-WHITE POWDER; ODORLESS.
Percent Volatiles by Volume:0 (WT)
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER. MATERIAL WILL HARDEN AND GENERATE HEAT WHEN WETTED.
Stability Condition to Avoid:NONE LISTED BY MANUFACTURER.
Hazardous Decomposition Products:SO*2 AND CAO ABOVE 1450C.
==================== Disposal Considerations ====================
Waste Disposal Methods:THIS MATERIAL IS DETERMINED NOT BE BE HAZARDOUS
WASTE AS PER RCRA STANDARDS EITHER BY LISTING OR CHARACTERISTICS.
DISPOSER MUST COMPLY WITH ALL FEDERAL, STATE AND LOCAL LAWS.
CONSIDER SENDING WASTE PR ODUCT TO A LANDFILL.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TONER FOR FACMILE TF541
CAGE:GO343
CAGE:GO343
============= Composition/Information on Ingredients =============
Ingred Name:MAGNETITE (FE3O4), IRON OXIDE
CAS:1317-61-9
Fraction by Wt: <60%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 MG/M3 TOT. PART.
ACGIH TLV:5 MG/M3 (FE) FUME
Ingred Name:STYRENE ACRYLATE COPOLYMER
CAS:25153-46-2
Fraction by Wt: <50%
Other REC Limits:NONE RECOMMENDED
Ingred Name:POLYPROPYLENE
CAS:9003-07-4
RTECS #:UD1842000
Fraction by Wt: <20%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SALICYLIC ACID CHELATE
CAS:72869-85-3
Fraction by Wt: <5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: <2%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3; 9394
Ingred Name:SILICA
CAS:68611-44-9
Fraction by Wt: <2%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 FOR THIS PRODUCT IS >5G/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES:MAY CAUSE IRRITATION.SKIN:MAY
CAUSE IRRITATION.INGEST:MAY CAUSE GI TRACT IRRITATION.INHAL:MAY
CAUSE RESPIRATORY IRRITATION.
Explanation of Carcinogenicity:THERE ARE NO INGREDIENTS ABOVE 0.1%
WHICH ARE IDENTIFIED AS CARCINOGENS BY NTP,IARC OR OSHA.
Effects of Overexposure:EYE/SKIN/RESPIRATORY IRRITATION.INGEST:POSSIBLE
DIARRHEA.
Medical Cond Aggravated by Exposure:UNLIKELY TO AGGRIVATE EXISTING
MEDICAL CONDITIONS.
======================= First Aid Measures =======================
First Aid:SKIN:REMOVE CONTAMINATED CLOTHING;WASH WITH SOAP AND
WATER.EYES:FLUSH WITH WATER FOR 15 MINUTES.INHAL:REMOVE TO FRESH
AIR.GIVE OXYGEN OR ARTIFICIAL RESPIRATION IF NEEDED.INGEST:GET
PROMPT QUALIFIED ME DICAL ATTENTION.IF CONSCIOUS,WASH MOUTHOUT WITH
WATER.
===================== Fire Fighting Measures =====================
Flash Point:>400F,>204C
Extinguishing Media:WATER,DRY CHEMICAL,CARBON DIOXIDE,FOAM.
Fire Fighting Procedures:USE A SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE EQUIPMENT.COOL FIRE EXPOSED CONTAINERS WITH WATER
FOG.
Unusual Fire/Explosion Hazard:THE FINELY DISPURSED DUST FROM THIS
PRODUCT IS A FIRE OR EXPLOSION HAZARD IN THE PRESENCE OF SOURCES OF
IGNITION.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP WITHOUT STIRRING UP.SOAK UP REMAINING
MATERIAL WITH NON-COMBUSTIBLE INERT ADSORBANT(EG.CLAY);PLACE
COLLECTED MATERIEL IN AN APPROPRIATE CONTAINER FOR DISPOSAL.
Neutralizing Agent:NONE
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS CLOSED.AVOID CONTACT
WITH EYES AND SKIN.KEEP AWAY FROM FOOD.
Other Precautions:AVOID HEATING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NEEDED IN NORMAL SERVICE.
Ventilation:NOT NEEDED IN NORMAL SERVICE.
Other Protective Equipment:NONE
Work Hygienic Practices:USE REASONABLE CARE IN HANDLING THIS
PRODUCT.WASH HANDS AFTER USE AND BEFORE EATING.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:>140F,>60C
Spec Gravity:1.0-1.9
Solubility in Water:NEGLIGIBLE
Appearance and Odor:POWDER;BLACK;NO ODOR.
Percent Volatiles by Volume:NIL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS(EG.HYDROGEN PEROXIDE).
Stability Condition to Avoid:CREATION OF DUST+SOURCES OF IGNITION.
Hazardous Decomposition Products:CARBON DIOXIDE,CARBON MONOXIDE,SULFUR
DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL,STATE AND
LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ORTHO CRABGRASS & DANDELION KILLER, AGC1000A
CAGE:085U5
CAGE:085U5
============= Composition/Information on Ingredients =============
Ingred Name:ARSONIC ACID, METHYL-, COMPOUND WITH 1-DODECANAMINE (1:1);
(DODECYLAMMONIUM ARSONATE)
CAS:53404-47-0
RTECS #:CH9550000
Fraction by Wt: 8%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ING 9:ELECTROLYTES. METALLIC TASTE, GARLIC ODOR OF BREATH &
STOOLS, DEHYDRATION, OLIGURIA, COLD & CLAMMY SKIN, (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10:GENERALIZED WEAK, FALL IN BLOOD PRESS, CONVLS,
FAINTING, COLLAPSE, SHOCK, COMA & DEATH. DEATHS AS LATE AS(ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11:14 DAYS AFTER POIS USUALLY CAUSED BY NEPHRITIS. IN
SOME CASES, ALIMENTARY SIGNS/SYMPS MAY BE MILD/ABSENT,(ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12:CNS INVOLVEMENT (HDCH, VERTIGO, MUSCLE SPASM,
STUPOR, DELIRIUM, MANIA). IN ADVANCED CASES OF POIS, (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13:PERIPHERAL NEURITIS (PARESTHESIA, HYPESTHESIA, PAIN.
EVENTUAL PARALYSIS & MUSCULAR ATROPHY MAY APPEAR IN (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14:LEGS) & ENCEPHALOPATHIES. INHAL:IRRIT OF UPPER RESP
TRACT, LARYNGITIS, BRONCH, HUSKINESS OF VOICE, LASS, (ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15:DYSP, CYANOSIS, COUGH W/FOAMY SPUTUM/PULM EDEMA.
PRLNG/RPTD EXPOS MAY RSLT IN PERFORATION OF NASAL SEPTUM.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC:CTR BEFORE INDUCING VOMIT. DO NOT INDUCE
VOMIT/GIVE ANYTHING BY MOUTH TO UNCON PERS. TAKE PERS & (ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17:PROD CNTNR TO NEAREST EMER TREATMENT CTR. INHAL:MOVE
PERS TO FRESH AIR. SEE MD IF DISCOMFORT/IRRIT CONTINUES.
RTECS #:9999999ZZ
Ingred Name:SPILL PROC:& PLACE IN DISP CNTNR. SCRUB CONTAM AREA
W/DETERGENT & WATER USING STIFF BROOM. PICK UP LIQ W/ADDNL (ING 20)
RTECS #:9999999ZZ
Ingred Name:ING 19:ABSORB & PLACE IN DISP CNTNR. DO NOT CONTAM WATER BY
CLEANING OF EQUIP/DISP OF WASTE. FOR HELP W/ANY (ING 21)
RTECS #:9999999ZZ
Ingred Name:ING 20:SPILL/LEAK/FIRE/EXPOS INVOLVING MATL, CALL
800-454-2333, OR CHEMTREC EMER #800-424-9300/202-483-7616 (24 HRS).
RTECS #:9999999ZZ
Ingred Name:OTHER PREC:NOT APPLY DIRECTLY TO WATER/WETLANDS. AVOID CONT
W/EYES, SKIN/CLTHG. KEEP OUT OF REACH OF CHILDREN. (ING 23)
RTECS #:9999999ZZ
Ingred Name:ING 22:IT IS A VIOLATION OF FED LAW TO USE THIS PROD IN A
MANNER INCONSISTENT W/ITS LABELING. READ ENTIRE LABEL.(ING 24)
RTECS #:9999999ZZ
Ingred Name:METHANEARSONOUS ACID, COMPOUND WITH OCTYLAMINE (1:1);
(OCTYLAMMONIUM ARSONATE)
CAS:6379-37-9
RTECS #:PA2800000
Fraction by Wt: 8%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ACETIC ACID, (2,4-DICHLOROPHENOXY)-, COMPOUND WITH
OCTYLAMINE (1:1); (OCTYLAMINE (2,4-DICHLOROPHENOXY) ACETATE)
CAS:2212-53-5
RTECS #:AG8380000
Fraction by Wt: <7.7%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:INERT INGREDIENTS
Fraction by Wt: <76.4%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ARSENIC (SARA 313) (CERCLA)
CAS:7440-38-2
RTECS #:CG0525000
Fraction by Wt: 4.1%
OSHA PEL:0.5 MG/M3 (MFR)
ACGIH TLV:0.01 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SUPDAT:SOLES). NAILS MAY BECOME BRITTLE & DEFORMED
DISPLAYING TRANSVERSE RIDGES, LOSS OF HAIR & NAILS, LOCALIZED (ING
7)
RTECS #:9999999ZZ
Ingred Name:ING 8:SUBCUTANEOUS EDEMA, WHICH BECOMES NOTICEABLE ON
EYELIDS. INGEST:SLIGHTLY TOX TO INTERNAL ORGS. CONSTRICTION(ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7:IN THROAT, DFCLTY SWALLOWING, COLLICKY PAIN IN
ESOPHAGUS, STOM & BOWELS (MAY BE FOLLOWED BY VIOLENT (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8:GASTROENTERITIS W/VOMIT & COPIOUS WATERY/BLOODY DIARR
WHICH LEADS TO MASSIVE LOSS OF BODY FLUIDS & (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 23:USE STRICTLY I/A/W LABEL PRECAUTIONARY STATEMENTS &
DIRECTIONS.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(ORAL,RAT) 3.3 G/KG.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:DEGREE OF INJURY WILL DEPEND ON AMT
ABSORBED FROM GUT; AMT OF MATL THAT GETS INTO EYE/ON SKIN & SPEED &
THOROUGHNESS OF FIRST AID TREATMENT. EYE:SEV IRRIT & COULD CAUSE
PERM DMG & BLINDNESS. MAY INCL PAIN, TEARS, SWELL, REDNESS &
BLURRED VISION. CORR (IRREVERSIBLE DESTRUCT OF OCULAR TISS); OR
CORNEAL (EFTS OF OVERXP)
Explanation of Carcinogenicity:ARSENIC:IARC MONO, SUPP, VOL 7, PG 100,
1987:GRP 1. NTP 7TH ANNUAL RPT ON CARCINS, 1994:KNOWN TO BE CARCIN.
OSHA(SUPDAT)
Effects of Overexposure:HLTH HAZ:INVOLVEMENT/IRRIT PERSISTING FOR >21
DAYS. SKIN:MOD IRRIT SO CONT COULD CAUSE PRLNG (DAYS) INJURY TO
AFFECTED AREA. MAY INCL PAIN/FEELING OF HEAT, DISCOLORATION, SWELL
& BLISTERING. CLINICAL PICTURE MAY INVOLVE ERUPTION,
ERYTHEMA,ULCERATION, ECZEMA, PIGMENTATION (MELANOSIS), SCALING,
DESQUAMATION & (SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH IMMED W/FRESH WATER FOR @ LST 15 MINS WHILE HOLDING
LIDS OPEN. REMOVE CONT LENSES. SEE MD FOR FURTHER TREATMENT ASAP.
SKIN:WASH THORO W/SOAP & WATER. REMOVE & WASH CONTAM CLTHG. SEE MD
IF AN Y SIGNS/SYMPS OCCUR. DISARD CONTAM NON-WATERPROOF
SHOES/BOOTS. INGEST:DRINK 1-2 GLASSES OF WATER/MILK & INDUCE VOMIT
BY TOUCHING BACK OF THROAT W/FINGER. IF POSS, CONT MD, POIS CTL
CTR/EMER (ING 17)
===================== Fire Fighting Measures =====================
Extinguishing Media:CO*2, DRY CHEMICAL, FOAM & WATER FOG.
Fire Fighting Procedures:USE NIOSH APPRVD SCBA & FULL PROT EQUIP. SMOKE
FROM FIRES INVOLVING MATL MAY PRESENT UNUSUAL HAZS. AVOID BRTHG
SMOKE & MISTS. AVOID CONT W/FALLOUT(SUPDAT)
Unusual Fire/Explosion Hazard:COMBUSTION MAY PRODUCE TOXIC COMPOUNDS OF
HALOGENS. TOXIC FUMES MAY BE GIVEN OFF WHEN MATERIAL IS EXPOSED TO
FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIM ALL OPEN FLAME IN VICIN OF SPILL/RELS
VAP. CLEAN UP SPILLS IMMED, OBSERVING PRECS IN EXPOS
CONTROLS/PERSONAL PROT SECTION. COVER SPILL W/GENEROUS AMT OF OIL
DRY, CAT LITTER, CLAY, RAGS/OTHER ABSO RB. USE STIFF BROOM TO MIX
THORO. SWEEPUP(ING 19)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT USE/STORE NEAR FLAME/SPKS/HOT
SURFS. USE ONLY IN WELL VENTED AREA. KEEP CHILDREN & ANIMALS AWAY
FROM TREATED AREA UNTIL THESE AREAS HAVE DRIED.
Other Precautions:KEEP PESTICIDE IN ORIGINAL CNTNR. DO NOT CONTAM
FOOD/FEED. DO NOT STORE UNDILUTED SPRAY. DO NOT PUT/DILUTE CONC IN
FOOD/DRINK CNTNRS. STORE IN SECURE, PREF LOCKED, COOL DRY STOR AREA
AWAY FROM HEAT, O PEN FLAME & DIRECT SUNLIGHT. DO (ING 22)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NO SPECIAL RESPIRATORY PROTECTION IS NORMALLY
REQUIRED. HOWEVER, BASED ON SKIN &/OR EYE IRRIT POTENTIAL, A NIOSH
APPROVED RESPIRATOR SHOULD BE MADE AVAILABLE IN CASE RESPIRATORY
IRRITATION OCCURS.
Ventilation:USE THIS MATERIAL ONLY IN WELL VENTILATED AREAS.
Other Protective Equipment:ANSI APPRVD EYE WASH FOUNTAIN & DELUGE
SHOWER . WEAR PROT CLTHG INCL LONG PANTS, LONG SLEEVED SHIRT & RUB
BOOTS.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
VP/VAP DENS:SAME AS WATER. EXPLAN OF CARCIN:REGULATED:29 CFR 1910.1018.
ANIMAL:LUNG & LYMPHATIC CANCER. EYE PROT:FULL LGTH FCSHLD . FIRE
FIGHT PROC:& RUNOFF. MIN AMT OF WATER USED FOR FIRE FIGHT ING.
CONTAIN & ISOLATE RUNOFF & DEBRIS FOR PROPER DISP. READ ENTIRE
DOCUMENT. EFTS OF OVEREXP:KERATOSIS (PALMS & (ING 6)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:210F,99C
Melt/Freeze Pt:M.P/F.P Text:<32F,<0C
Vapor Pres:SUPP DATA
Vapor Density:SUPP DATA
Spec Gravity:1.06
Solubility in Water:SOLUBLE
Appearance and Odor:AMBER TO BROWN LIQUID.
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT W/ACTIVE METALS. MAY REACT W/STRONG ACIDS/STRONG
OXIDIZING AGENTS (CHLORATES, NITRATES, PEROXIDES, ETC).
Stability Condition to Avoid:AVOID HIGH TEMPERATURES.
Hazardous Decomposition Products:HEATING THIS PRODUCT MAY PRODUCE
AMINES & AMMONIA.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISP MUST BE I/A/W FED, STATE & LOC REGS.
PARTIALLY FILLED CNTNR MAY BE DISP OF BY SECURELY WRAPPING ORIGINAL
CNTNR IN SEVERAL LAYERS OF NEWSPAPER & DISCARD IN TRASH. DO NOT
REUSE EMPTY CNTNR. R INSE EMPTY CNTNR THORO BEFORE DISCARDING IN
TRASH.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:EPOXY RESIN, FE-3026-A
Preparer's Name:INDUSTRIAL HYGIENE
CAGE:0HD19
CAGE:0HD19
============= Composition/Information on Ingredients =============
Ingred Name:EPOXY RESIN
Fraction by Wt: >10%
Ingred Name:RESORCINOL(SARA III)
CAS:108-46-3
RTECS #:VG9625000
Fraction by Wt: 1-10%
OSHA PEL:10 PPM/20 STEL
ACGIH TLV:10 PPM/20 STEL; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: DIRECT EYE CONTACT WITH THE
PRODUCT MAY CAUSE IRRITATION. SKIN: EPOXY RESINS ARE POTENTIAL
DERMAL SENSITIZERS. INHAL: INHALATION IS NOT A ROUTE OF EXPOSURE.
(CHRONIC) NO ANTICIPATED CHRONIC EFFE CTS.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH IMMEDIATELY W/WATER FOR AT LEAST 15 MINUTES. CALL
MD IF IRRITATION PERSISTS. SKIN: WASH AFFECTED AREA WITH SOAP AND
WATER. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE. INGEST: CALL MD
IMMED IATELY . INHAL: REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE
O2/ARTIFICIAL RESPIRATION) .
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:>200F,>93C
Extinguishing Media:USE WATER SPRAY, FOAM, DRY CHEMICAL OR CO2.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE KNOWN.
================== Accidental Release Measures ==================
MATERIAL. RESIDUE MAY BE REMOVED WITH A CHLORINATED SOLVENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY LOCATION.
Other Precautions:LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NORMALLY REQUIRED. NIOSH/MSHA APPROVED
RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:STANDARD INDUSTRIAL VENTILATION.
Other Protective Equipment:PROTECTIVE CLOTHING.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
WASTE DISP METH: FEDERAL, STATE & LOCAL REGULATIONS . FOR ADDITIONAL
WASTE DISPOSAL ASSISTANCE CONSULT H B FULLER ENVIRONMENTAL SERVICES
612/481-1588.
================== Physical/Chemical Properties ==================
HCC:T4
Vapor Pres:SEE INGRED
Appearance and Odor:LIQUID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:INCOMPLETE COMBUSTION CAN YIELD LOW
MOLECULAR WEIGHT HYDROCARBONS, CO, NITROGEN COMPOUNDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:THIS PROD DOES NOT MEET DEFINITION OF HAZ WASTE
UNDER U.S. EPA HAZ WASTE REGS 40 CFR 261. STATE/LOCAL HAZ WASTE
REGS MAY APPLY IF THEY ARE DIFFERENT FROM FED REG.
INCINERATE/DISPOSE OF IN AN APPRVD IN DUSTRIAL LANDFILL. DISPOSE OF
I/A/W (SUPP DATA)
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:RED OCCLUDE
Preparer's Name:JOE PELLICANO
CAGE:22992
CAGE:22992
============= Composition/Information on Ingredients =============
Ingred Name:PROPANE, 2-METHYL-; (ISOBUTANE) (PROPELLANT)
CAS:75-28-5
RTECS #:TZ4300000
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYES:DISCOMFORT IF SPRAYED INTO
EYES. INHLATION:ISOBUTANE MAY DISPLACE OXYGEN IN REACHING LUNGS.
INGESTION:NORMAL QUANTITIES IS NONTOXIC. NAUSEA, DIZZINESS MAY
OCCUR FROM INHALATION OF PROPELLEN T.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:SEE MEDICAL ASSISTANCE FOR FURTHER TREATMENT, OBSERVATION AND
SUPPORT IF NECESSARY. INGEST:CALL MD IMMEDIATELY . EYE:FLUSH WELL
WITH WATER FOR @ LEAST 15 MINS, SEEK MED ATTN. SKIN:EXCESSIVE EXPO
SURE MAY CAUSE FROSTBITE. TREAT AS SUCH. INHAL:IF UNCONSCIOUS, GIVE
OXYGEN.
===================== Fire Fighting Measures =====================
Lower Limits:1.8%
Upper Limits:8.4%
Extinguishing Media:CO*2, DRY CHEMICAL/WATER.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . CONFINE FIRE TO IMMEDIATE AREA.
Unusual Fire/Explosion Hazard:N-BUTANE HAS SEVERE FIRE AND EXPLOSIVE
POTENTIAL MAY REACT WITH OXIDIZING MATERIAL.
================== Accidental Release Measures ==================
Spill Release Procedures:PROVIDE ADEQUATE VENTILATION, USE SOAP AND
WATER AFTER PROPELLENT HAS BEEN DISPERSED.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:FLAMMABLE:KEEP AWAY FROM FIRE. DO NOT
PUNCTURE.
Other Precautions:NONE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT RECOMMENDED. NIOSH/MSHA APPROVED RESPIRATOR
APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:MECHANICAL (GENERAL):RECOMMENDED.
Other Protective Equipment:LAB COAT OR JACKET TO PROTECT CLOTHING. ANSI
APPRVD EMERGENCY EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:11F,-12C
Vapor Pres:45.09 @70F
Vapor Density:2.010
Spec Gravity:0.5631(H*2O=1)
Solubility in Water:NONE
Appearance and Odor:RED POWDER WITH ODOR OF PROPELLANT.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIALS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:USED CONTAINERS MAY BE DISPOSED OF IN GARBAGE.
DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL REGULATIONS .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SEMI-GLOSS ENAMEL GRAY, TT-E-529
CAGE:6F266
CAGE:6F266
============= Composition/Information on Ingredients =============
Ingred Name:LIGROINE; (MINERAL SPIRITS)
CAS:8032-32-4
RTECS #:OI6180000
Fraction by Wt: 27.0%
OSHA PEL:300 PPM
ACGIH TLV:300 PPM
Ingred Name:VOLATILE ORGANIC COMPOUND:370 GRAMS/LITER (LESS WATER)
RTECS #:9999999VO
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN:THIS MATERIAL MAY CAUSE
IRRITATION, SENSITIZATION OR DEFATTING OF SKIN UPON PROLONGED OR
REPEATED CONTACT. INHALATION:EXCESSIVE EXPOSURE TO VAPORS OR SPRAY
MISTS CAN RESULT IN HEADACHE, DIZZINESS , NAUSEA AND LOSS OF
CONSCIOUSNESS. SOME REPORTS HAVE ASSOCIATED REPEATED AND PROLONGED
OCCUPATIONAL (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZS:OVEREXPOSURE TO SOLVENTS WITH
PERMANENT BRAIN AND NERVOUS SYSTEM DAMAGE. EYES:THIS MATERIAL MAY
BE AN EYE IRRITANT.
Medical Cond Aggravated by Exposure:NONE, WHEN USED IN ACCORDANCE WITH
SAFE HANDLING INSTRUCTIONS. (SEE HANDLING AND STORAGE PRECAUTIONS).
======================= First Aid Measures =======================
First Aid:SKIN:PROMPTLY WASH WITH SOAP AND WATER. REMOVE AND WASH ANY
CONTAMINATED CLOTHING BEFORE REUSE. EYES:FLUSH W/LG QTYS OF WATER
FOR @ LST 15 MIN AND SEEK MED ATTN. INGEST:DO NOT INDUCE VOMIT,
KEEP PERSO N WARM, QUIET & GET MED ATTN. ASPIR OF MATL INTO LUNGS
CAN CAUSE CHEM PNEUM WHICH CAN BE FATAL. INHAL:REMOVE TO FRESH AIR
IMMED. IF RESP SYMPS DEVELOP, SEEK MED ATTN AT ONCE.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:107F,42C
Lower Limits:0.7%
Extinguishing Media:FOAM, CO*2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. WATER MAY BE UNSUITABLE AS EXTING MEDIUM, BUT HELPFUL IN KEEPING
ADJACENT CNTNRS COOL. EVACUATE (SUP DAT)
Unusual Fire/Explosion Hazard:VAPORS MAY FORM AN EXPLOSIVE MIXTURE IN
AIR AND MAY BE IGNITED BY SPARKS, PILOT LIGHTS, ETC. CLOSED
CONTAINERS MAY RUPTURE WHEN EXPOSED TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNIT. VENT AREA. ABSORB
SPILL W/ABSORB MATL SUCH AS SAWDUST, VERMICULITE/SAND & PLACE MATL
INTO CLSD CNTNR. IF LG SPILL, DIKE AREA TO PVNT MATL FROM ENTERING
WATER SYSTEMS OR SE WERS. WEAR PROT EQUIP DURING CLEANUP.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID PROLONGED OR REPEATED INHALATION
OF HEATED VAPORS OR SPRAY MISTS. KEEP AWAY FROM HEAT OR OPEN FLAME.
THIS MATERIAL MAY CAUSE SENSITIZATION.
Other Precautions:DO NOT GET IN EYES, ON SKIN OR CLOTHING. DO NOT ALLOW
CONTAMINATED CLOTHING TO CONTACT SKIN. DO NOT WELD ON FULL OR EMPTY
CONTAINERS. KEEP CONTAINERS CLOSED, WHEN NOT IN USE, AND PROPERLY
LABELED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED CANISTER-TYPE RESPIRATOR
MUST BE WORN TO PREVENT INHALATION OF VAPORS OR SPRAY MISTS WHEN
TLV OR PEL IS EXCEEDED.
Ventilation:GEN VENT IS REQ DURING NORMAL USE. LOC VENT MAY BE REQ
DURING CERTAIN OPERATIONS TO KEEP EXPOS LEVEL BELOW LIMS IN INGS.
Other Protective Equipment:WEAR PROTECTIVE CLOTH TO PREVENT SKIN CONT.
EMERG EYE WASH & DELUGE SHOWER WHICH MEET ANSI DESIGN CRITERIA .
Work Hygienic Practices:WASH HANDS BEFORE EATING OR SMOKING.
Supplemental Safety and Health
FIRE FIGHT PROC:AREA OF UNPROTECTED PERSONNEL. WASTE DISP METH:ACCORD
W/LOC, STATE & FED AGENCIES. GROUND HNDLG EQUIP TO PVNT SPKS. FOR
FURTHER INFO:CONT YOUR STATE/LOC WASTE AGENCY/UNITED STATES ENVI
RON PROT AGENCY'S RCRA HOTLINE (1-800-424-9346/1-202-382-3000).
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>307F,>153C
Vapor Pres:2.6 @ 20C
Vapor Density:HVR/AIR
Spec Gravity:1.37
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NIL
Appearance and Odor:WHITE OR COLORED LIQUID, MILD PLEASANT ODOR.
Percent Volatiles by Volume:46.0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDANTS, ACIDS, BASES AND EPOXY HARDENERS
UNDER UNCONTROLLED CONDITIONS.
Stability Condition to Avoid:HEAT, SPARKS AND OPEN FLAMES. IF PRODUCT
CONTAINS ALUMINUM, MOISTURE IN CLOSED CONTAINERS WILL GENERATE
HYDROGEN GAS.
Hazardous Decomposition Products:INCOMPLETE COMBUSTION CAN YIELD CARBON
MONOXIDE AND TOXIC VAPORS.
==================== Disposal Considerations ====================
Waste Disposal Methods:IF DISCARDED, MATL & CNTNRS SHOULD BE TREATED AS
HAZ WASTES BASED ON CHARACT OF IGNITABILITY AS DEFINED UNDER FED
RCRA REGS (40 CFR 261). DISP OF MATL/ITS CNTNR REQS COMPLIANCE
W/APPLIC LBLING, PACKAG ING & RECORDKEEPING STANDARDS. DISP IN (SUP
DAT)
| 1 | gloves_mandatory |
Subsets and Splits
No community queries yet
The top public SQL queries from the community will appear here once available.