text
stringlengths 542
18.7k
| label
int64 0
1
| label_text
stringclasses 2
values |
|---|---|---|
===================== Product Identification =====================
Product ID:TT-E-490 SI/ALKYD WHITE
Preparer's Name:PATRICIA SHAW
CAGE:HO931
CAGE:3Z268
CAGE:HO931
============= Composition/Information on Ingredients =============
Ingred Name:HYDROCARBON MIXTURE (VAPOR PRESSURE 2.0 MM HG @ 68 F)
CAS:64741-41-9
Fraction by Wt: 30%
Other REC Limits:NONE SPECIFIED
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
Ingred Name:TALC
CAS:14807-96-6
RTECS #:WW2710000
Fraction by Wt: 10%
Other REC Limits:NONE SPECIFIED
ACGIH TLV:2 MG/M3 RESP DUST
Ingred Name:MICA
CAS:12001-26-2
RTECS #:VV8760000
Fraction by Wt: <5.0%
Other REC Limits:NONE SPECIFIED
OSHA PEL:20 MPPCF
ACGIH TLV:3 MG/M3 RDUST; 9293
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL: NASAL & RESP IRRIT, NARCOSIS
(CNTRL NERV SYS DEPRESS). EYE: SEVERE IRRIT. SKIN: IRRIT, DEFAT,
DERMATITIS. INGEST: DIGEST TRACT IRRIT, CNTRL NERV SYS DEPRESS.
ASPIRATION HZD. MAT'L ENTER LUNGS ( SWALLOW/VOMIT), CAUSE LUNG
INFLAMM. CHRONIC: CNTRL NERV SYS/RESP SYS/LUNG/EYE/SKIN/GI
TRACT/LIVER/SPLEEN/KIDNEY DAMAGE.
Effects of Overexposure:INHALATION: DIZZINESS, WEAKNESS, FATIGUE,
NAUSEA, AND HEADACHE. EYE: TEARING, REDNESS, AND BLURRED VISION.
Medical Cond Aggravated by Exposure:RESPIRATORY TRACT IRRITATION,
DERMATITIS, NAUSEA.
======================= First Aid Measures =======================
First Aid:EYE: FLUSH W/WATER 15 MIN, OCCASIONALLY LIFTING EYELIDS. GET
MED ATTN. SKIN: REMOVE CONTAMINATED CLOTHING, WASH W/SOAP & WATER.
IF IRRITATION PERSISTS, SEE DR. INHAL: REMOVE TO FRESH AIR. APPLY
ARTIF RESPIRATION/ADMINISTER OXYGEN IF NEEDED. CONSULT DR. INGEST:
UNLESS DIRECTED BY MED PERSONNEL. IF ADVICE UNAVAIL, TAKE TO EMERG
ROOM.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:102F,39C
Lower Limits:1.0
Upper Limits:6.1
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:USE EXTINGUISHER (NFPA FLAMMABLE LIQ FIRE).
WATER MAY BE INEFFECTIVE, USE AS FOG FOR COOLING. WEAR FULL
PROTECTIVE CLOTHING & BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:VAPORS FORM EXPLOSIVE MIX W/AIR (LEL TO
UEL) WHICH CAN BE IGNITED BY MANY SOURCES. CLOSED CNTNRS MAY
EXPLODE W/HEAT. ISOLATE FROM HEAT/IGNITION SOURCES.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE ALL NON-ESSENTIAL PERSONNEL. REMOVE
ALL IGNITION SOURCES. VENTILATE AREA. PROVIDE PROTECTIVE EQUIPMENT.
DIKE AROUND SPILL AREA. COVER SPILL WITH INERT ABSORBENT AND
TRANSFER USING NON-SPARKIN G TOOLS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE BELOW 80 F IN CLOSED CONTAINER.
STORE IN ORIGINAL CONTAINER. AVOID FLAME AND HIGH TEMPERATURES. DO
NOT STORE NEAR OXIDIZING AGENTS OR ACIDS.
Other Precautions:VAPOR IS HEAVIER THAN AIR, MAY TRAVEL CONSIDERABLE
DISTANCE TO IGNITION SOURCE & FLASHBACK. DON'T INGEST OR INHALE.
GROUND ALL CONNECTIONS, CONTAINERS, ETC WHEN POURING OR TRANSFERING
TO MINIMIZE STAT IC ELECTRICITY. USE NON-SPARK TOOLS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA EQUIPMENT WHEN AIRBORNE EXPOSURE
LIMITS ARE EXCEEDED. CONSULT RESPIRATOR MANUFACTURER TO DETERMINE
EQUIPMENT FOR GIVEN APPLICATION. HIGH AIRBORN CONCENTRATIONS MAY
REQUIRE USE OF SUPPLI ED-AIR RESPIRATOR OR SCBA.
Ventilation:PROVIDE VENTILATION TO CONTROL EXPOSURE LEVELS BELOW
AIRBORNE EXPOSURE LIMITS. VENT EQUIPMENT MUST BE EXPLOSION PROOF.
Other Protective Equipment:WEAR IMPERMEABLE APRONS & PROTECT CLOTHES
WHEN POSSIBLE TO PREVENT REPEAT/EXTEND EXPOSURE OF SKIN. HEAD CAPS
RECOMMENDED
Work Hygienic Practices:AFTER USING, WASH BEFORE EATING, TOILETING OR
SMOKING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:274 TO 315F
Vapor Density:> AIR
Spec Gravity:1.3 (WATER=1)
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NOT WATER SOLUBLE
Appearance and Odor:PIGMENTED LIQUID. SOLVENT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:DO NOT EXPOSE TO HEAT OR IGNITION SOURCES.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY YIELD CARBON
DIOXIDE AND/OR MONOXIDE, LOW MOLECULAR WEIGHT HYDROCARBONS &
ORGANIC ACIDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:KEEP OUT OF DRAINS, SEWERS AND WATERWAYS.
DISPOSE OF PRODUCT IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:COUMARIN 152
CAGE:19139
CAGE:19139
============= Composition/Information on Ingredients =============
Ingred Name:COUMARIN 152
CAS:53518-14-2
Fraction by Wt: 100%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:THE TOXICOLOGICAL PROPERTIES OF THIS
MATERIAL HAVE NOT BEEN INVESTIGATED, EXERCISE APPROPRIATE
PROCEDURES TO PREVENT OPPORTUNITIES FOR DIRECT CONTACT W/SKIN OR
EYES & TO PREVENT INHALATION.
Explanation of Carcinogenicity:MANUFACTURER GAVE NO INFORMATION ABOUT
CARCINOGENICITY. HMIS DOES NOT EXPECT IT TO BE CARCINOGENIC.
Effects of Overexposure:MFR GAVE NO INFORMATION ON MSDS.
Medical Cond Aggravated by Exposure:MFR GAVE NO INFORMATION ON MSDS.
======================= First Aid Measures =======================
First Aid:INHALAATION:REMOVE TO FRESH AIR. TREAT SYMPTOMATICALLY.IF
SYMPTOMS ARE PRESENT, GET MEDICAL ATTENTION. EYES:IMMEDIATELY FLUSH
EYES W/PLENTY OF WATER FOR AT LEAST 15 MINUTES & GET MEDICAL
ATTENTION.S KIN:IMMEDIATELY FLUSH SKIN W/PLENTY OF WATER FOR AT
LEAST 15 MINUTES & GET MEDICAL ATTENTION IF SYMPTOMS ARE PRESENT
AFTER WASHING. INGESTION:DRINK 1-2 GLASSES OF WATER OR MILK. CALL A
PHYSICIAN.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER SPRAY, DRY CHEMICAL, CARBON DIOXIDE
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS &
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY CAUSE
PRODUCTION OF HAZARDOUS DECOMPOSITION PRODUCTS.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP MATERIAL & PACKAGE FOR SAGE FEED TO
AN INCINERATOR.
Neutralizing Agent:MFR GAVE NO INFORMATION ON MSDS.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP FROM CONTACT W/OXIDIZING
MATERIALS.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:A NIOSH APPROVED DUST RESPIRATOR SHOULD BE WORN
IF NEEDED.
Ventilation:GOOD GENERAL ROOM VENTILATION SHOULD BE USED. LOCAL EXHAUST
MAY BE NEEDED.
Other Protective Equipment:MFR GAVE NO INFORMATION ON MSDS.
Work Hygienic Practices:EK: ? HMIS:USE GOOD INDUSTRIAL HYGIENE
PRACTICES. MINIMIZE PERSONAL CONTACT. WASH THOROUGHLY AFTER
HANDLING.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:N1
NRC/State Lic Num:NONE
Melt/Freeze Pt:M.P/F.P Text:NOT AVAIL.
Vapor Pres:NEGLIGLBLE
Spec Gravity:NOT AVAILABLE
Evaporation Rate & Reference:NEGLIGLBLE
Solubility in Water:NOT AVAILABLE
Appearance and Odor:YELLOW SOLID; ODORLESS
Percent Volatiles by Volume:NEGLIG
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STORNG OXIDIZERS
Stability Condition to Avoid:MFR GAVE NO INFORMATION ON MSDS.
Hazardous Decomposition Products:COMBUSTION WILL PRODUCE CARBON DIOXIDE
& PROBABLY CARBON MONOXIDE. OXIDES OF NITROGEN & HF GAS MAY ALSO BE
PRESENT.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE BY INCINERATION OR CONTRACT W/LICENSED
CHEMICAL WASTE DISPOSAL AGENCY. DISCHARGE, TREATMENT OR DISPOSAL
MAY BE SUBJECT TO FEDERAL, STATE & LOCAL LAWS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:HANDPIECE LUBRICANT, MIDWEST PLUS
Kit Part:Y
Preparer's Name:PAB
CAGE:NO562
CAGE:NO562
CAGE:81490
============= Composition/Information on Ingredients =============
Ingred Name:NON-HAZARDOUS INGREDIENTS
Fraction by Wt: 100%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LIMIT FOR AIRBORNE: 5 MG/M3
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: POSSIBLE SKIN AND EYE
IRRITATION. POSSIBLE PASSAGE IRRITATION AT HIGH TEMPERATURES.
CHRONIC: NONE KNOWN.
Explanation of Carcinogenicity:THIS PRODUCT IS NOT CONSIDERED A HUMAN
CARCINOGEN BY ANY RECOGNIZED SOURCE.
Effects of Overexposure:THERE IS NO EXPERIENCE WITH OVEREXPOSURE.
PROLONGED OR REPEATED CONTACT WITH THE SKIN OR CONTACT WITH THE EYE
MAY CAUSE IRRITATION. INHALATION OF MIST OR VAPORS FROM MATERIAL AT
HIGH TEMPERATURES MAY IRRITATE RESPIRATORY PASSAGES.
Medical Cond Aggravated by Exposure:NONE.
======================= First Aid Measures =======================
First Aid:EYE CONTACT-WASH THOROUGHLY, CONTACT PHYSICIAN IF IRRITATION
PERSISTS. SKIN CONTACT-WASH WITH SOAP AND WATER. INHALATION-MOVE TO
FRESH AIR AND REFER TO A PHYSICIAN FOR TREATMENT.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:455F,235C
Extinguishing Media:CARBON DIOXIDE, FOAM, DRY CHEMICAL, WATER SPRAY.
Fire Fighting Procedures:AVOID SMOKE INHALATION. WATER OR FOAM MAY
CAUSE FROTHING.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE FREE LIQUID. ADD ABSORBENT (SAND,
EARTH, SAWDUST) TO SPILL AREA. AFTER REMOVING ABSORBENT, WASH
WALKING SURFACES THOROUGHLY WITH DETERGENT AND WATER TO REDUCE
SLIPPING HAZARD.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:EXERCISE ORDINARY CARE IN HANDLING
CHEMICALS.
Other Precautions:AVOID CONTAMINATION OF CIGARETTE OR OTHER TOBACCO
PRODUCTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED UNLESS MISTS, SMOKE OR VAPOR ARE
PRODUCED AT HIGH TEMPERATURES.
Ventilation:NONE REQUIRED UNLESS MISTS, SMOKE OR VAPORS ARE PRODUCED AT
HIGH TEMPERATURES.
Other Protective Equipment:NOT NEEDED.
Work Hygienic Practices:WASH HANDS THOROUGHLY BEFORE SMOKING.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:-50F,-46C
Vapor Pres:10-4 TORR
Vapor Density:>AIR
Spec Gravity:0.83
pH:7
Evaporation Rate & Reference:SLOWER THAN DIETHYL ETHER
Solubility in Water:INSOLUBLE.
Appearance and Odor:CLEAR, COLORLESS SYNTHETIC OIL.
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING MATERIALS.
Stability Condition to Avoid:PYROLYSIS.
Hazardous Decomposition Products:BURNING MAY PRODUCE CARBON MONOXIDE AS
WELL AS SMALL AMOUNTS OF OTHER TOXIC FUMES.
Conditions to Avoid Polymerization:AVOID CONTAMINATION OF CIGARETTES OR
OTHER TOBACCO PRODUCTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:MANY STATES CLASSIFY WASTE LUBRICANTS AS
"HAZARDOUS", WHICH MEANS DISPOSAL ONLY BY A LICENSED FIRM. CONSULT
LOCAL, STATE AND FEDERAL REGULATIONS APPLICABLE TO YOUR AREA.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:92-78379-12 QUICKSILVER CORROSION GUARD
CAGE:GO139
CAGE:88907
CAGE:GO139
============= Composition/Information on Ingredients =============
Ingred Name:STODDARD SOLVENT (PETROLEUM DISTILLATE), MINERAL SPIRITS
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 40%
Other REC Limits:350 MG/CUM
OSHA PEL:500 PPM
ACGIH TLV:100 PPM; 9293
Ingred Name:ISOBUTANE, 2-METHYLPROPANE
CAS:75-28-5
RTECS #:TZ4300000
Fraction by Wt: 15%
Other REC Limits:1000 PPM
OSHA PEL:1800 MG/CUM
ACGIH TLV:1000 PPM
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 15%
Other REC Limits:1800 MG/CUM
OSHA PEL:1000 PPM
ACGIH TLV:SIMPLE ASPHYXIANT
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: IRRITATION. INHALATION:
PERMANENT BRAIN/NERVOUS SYSTEM/KIDNEY/LIVER DAMAGE, UPPER
RESPIRATORY SYSTEM IRRITATION, LIGHT HEADEDNESS, STAGGERING GAIT,
GIDDINESS, ANESTHETIC EFFECTS, & NAUSEA. INGES TION: HARMFUL &
FATAL.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SKIN: IRRITATION. INHALATION: PERMANENT
BRAIN/NERVOUS SYSTEM/KIDNEY/LIVER DAMAGE, UPPER RESPIRATORY SYSTEM
IRRITATION, LIGHT HEADEDNESS, STAGGERING GAIT, GIDDINESS,
ANESTHETIC EFFECTS, & NAUSEA. INGES TION: HARMFUL & FATAL.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MINS. SKIN:
WASH THOROUGHLY W/SOAP & WATER. INHALATION: REMOVE TO FRESH AIR.
INGESTION: DON'T INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TOC
Flash Point:<20F
Lower Limits:1%
Extinguishing Media:CO2, DRY CHEMICAL, FOAM
Fire Fighting Procedures:WATER MAY BE INEFFECTIVE BUT MAY BE USED TO
KEEP FIRE EXPOSED CONTAINERS COOL.
Unusual Fire/Explosion Hazard:KEEP AT ROOM TEMPERATURE AS EXPOSURE TO
DIRECT SUNLIGHT OR HEAT MAY CAUSE BURSTING.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE IGNITION SOURCES. VENTILATE AREA.
REMOVE W/INERT ABSORBENT MATERIALS.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T STORE >120F. KEEP AT ROOM
TEMPERATURE AS EXPOSURE TO DIRECT SUNLIGHT OR HEAT MAY CAUSE
BURSTING. KEEP OUT OF REACH OF CHILDREN.
Other Precautions:DON'T PUNCTURE OR INCINERATE. DON'T SPRAY NEAR FIRE
OR OPEN FLAME. CONTENTS UNDER PRESSURE (50-60 PSIG). AVOID
INHALATION OF VAPORS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:ORGANIC VAPOR CARTRIDGE RESPIRATOR OR
SELF-CONTAINED BREATHING APPARATUS.
Ventilation:LOCAL EXHAUST: PROVIDE IN VOLUME. MECHANICAL (GENERAL):
ADEQUATE SHORT TERM ONLY.
Other Protective Equipment:FACESHIELD, APRON
Work Hygienic Practices:FOLLOW GOOD HOUSEKEEPING & PERSONAL HYGIENE
PRACTICES.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:<0F
Vapor Density:>1
Evaporation Rate & Reference:(BU AC = 1): >1
Appearance and Odor:COLORLESS LIQUID W/SOLVENT ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:TEMPS >120F, FIRE, OPEN FLAME, DIRECT
SUNLIGHT, HEAT, & OTHER IGNITION SOURCES
Hazardous Decomposition Products:CO, CO2
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS REGARDING POLLUTION. DON'T INCINERATE OR
PUNCTURE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TAPE DRIVE CLEANING KIT, TUC02
CAGE:15476
CAGE:15476
============= Composition/Information on Ingredients =============
Ingred Name:1,1,2-TRICHLORO-1,2,2-TRIFLUOROETHANE (FREON 113) (SARA
III)
CAS:76-13-1
RTECS #:KJ4000000
Fraction by Wt: 100%
OSHA PEL:1000PPM/1250STEL
ACGIH TLV:1000PPM/1250STEL9192
Ozone Depleting Chemical:1
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(ORAL RAT)>5 G/KG.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EXPOSURE BY INHALATION AND SKIN
POSSIBLE. OVEREXPOSURE MAY CAUSE LOSS OF MANUAL DEXTERITY AND
NARCOSIS. CARDIAC SENSITIZATION MAY OCCUR. CHRONIC/OTHER:DATA SHOW
THAT THERE ARE NO MUTAGENIC OR REPRODUC TIVE EFFECTS. CHLOROCARBON
MATERIALS HAVE PRODUCED SENSITIZATION OF THE MYOCARDIUM TO
EPINEPHRINE (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:IN LABORATORY ANIMALS AND COULD HAVE A
SIMILAR EFFECT IN HUMANS. ADRENOMIMETICS (E.G., EPINEPHRINE) MAY BE
CONTRAINDICATED EXCEPT FOR LIFE-SUSTAINING USES IN HUMANS ACUTELY
OR CHRONICALLY EXP OSED TO CHLOROCARBONS .
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. SUPPPORT BREATHING IF NECESSARY
AND CALL MD. SKIN:PROMPTLY WASH WITH SOAP & WATER. IF IRRITATION
PERSISTS AFTER WASHING, CALL MD. EYE:FLUSH WITH LARGE QUANTITIES OF
WATER FO R AT LEAST 15 MINUTES. INGEST:DO NOT INDUCE VOMITING. GET
MD IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point:32.0F,0.0C
Extinguishing Media:USE MEDIA SUITABLE FOR SURROUNDING FIRE CONDITIONS
.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED PRESSURE DEMAND SCBA
AND FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:THERMAL DECOMPOSITION PRODUCTS MAY
INCLUDE FLUORIDES, CHLORIDES AND PHOSGENE .
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT MATERIAL SUCH AS VERMICULITE OR
DRY SAND. VENTILATE AREA OF LEAK/SPILL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED AND IN A
VENTILATED AREA BELOW 125F. KEEP CONTAINER CLOSED AND IN COOL,
VENTILATED AREA.
Other Precautions:MAY ATTACK SOME PLASTICS, RUBBER AND COATING. NO
SMOKING IN AREA OF USE. DO NOT USE IN GENERAL VICINITY OF ARC
WELDING, OPEN FLAMES OR HOT SURFACES. HEAT AND/OR UV RADIATION MAY
CAUSE FORMATION OF FLU ORIDES, CHLORIDES &/OR PHOSGENE .
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:118F,48C
Vapor Pres:284 @ 20C
Vapor Density:6.5
Spec Gravity:1.55
Evaporation Rate & Reference:>1 (BUTYL ACETATE=1)
Solubility in Water:O.17 @ 100C
Appearance and Odor:CLEAR COLORLESS LIQUID.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACTIVE METALS, POWDERED ALUMINIM, ZINC, BERYLLIUM, CALCIUM.
Stability Condition to Avoid:DECOMPOSED BY FLAME AND RED, HOT SURFACES.
Hazardous Decomposition Products:CO, CO2, HYDROGEN FLUORIDE, HCL,
PHOSGENE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF USED PRODUCT AS RUBBISH.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:NORMAL SOLVENT BLEND
CAGE:0LNB7
CAGE:0LNB7
CAGE:0T5C6
============= Composition/Information on Ingredients =============
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Other REC Limits:NONE SPECIFIED
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:PETROLEUM DISTILATE, (VM&P NAPTHA)
CAS:8032-32-4
RTECS #:OI6180000
Other REC Limits:NONE SPECIFIED
OSHA PEL:300 PPM
ACGIH TLV:300 PPM9293
Ingred Name:ETHYL ACETATE (SARA III)
CAS:141-78-6
RTECS #:AH5425000
Other REC Limits:NONE SPECIFIED
OSHA PEL:400 PPM
ACGIH TLV:400 PPM 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)
CAS:78-93-3
RTECS #:EL6475000
Other REC Limits:NONE SPECIFIED
OSHA PEL:200 PPM/300 STEL
ACGIH TLV:200 PPM/300STEL 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ISOPROPYL ALCOHOL (SARA III)
CAS:67-63-0
RTECS #:NT8050000
Other REC Limits:NONE SPECIFIED
OSHA PEL:400 PPM/500 STEL
ACGIH TLV:400 PPM/500STEL;9293
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT) IS UNKNOWN.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION. SKIN: MILD
IRRITATION. INHALATION: MAY CAUSE IRRITATION, DIZZINESS, HEADACHE,
AND SIGNS OF CNS DEPRESSION. INGESTION: MAY CAUSE NAUSEA, VOMITING,
HEADACHE, AND DIZZINESS.
Effects of Overexposure:EYES: IRRITATION, REDNESS AND BURNING OF THE
EYES. SKIN: IRRITATION, REDNESS, CRACKING, DRYNESS. INHALATION:
IRRITATION, DIZZINESS, HEADACHE, SIGNS OF CNS DEPRESSION.
INGESTION: NAUSEA, VOMITING, HEAD ACHE, DIZZINESS.
Medical Cond Aggravated by Exposure:PRE-EXISTING DERMATITIS, LUNG
DISORDERS.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH LARGE AMOUNTS OF WATER. IF IRRITATION
PERSISTS GET MEDICAL ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING.
WASH AREA WITH SOAP AND WATER. IF IRRITATION PERSISTS, GET MEDICAL
ATTENTION.INHALATION: MOVE TO FRESH AIR.IF NOT BREATHING GIVE
CPR. IF BREATHING DIFFICULT GIVE OXYGEN.GET MEDICAL ATTENTION.
INGESTION: POTENTIAL ASPIRATION HAZARD.GET MEDICAL ATTENTION.DO NOT
LEAVE UNATTENDED
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:30.0F,-1.1C
Extinguishing Media:FOAM, WATER SPRAY, DRY CHEMICAL, CARBON DIOXIDE.
Fire Fighting Procedures:USE WATER SPRAY TO COOL CONTAINERS EXPOSED TO
FIRE. AVOID SPREADING BURNING LIQUID WITH WATER USED FOR COOLING
PURPOSES.
Unusual Fire/Explosion Hazard:VAPORS MAY TRAVEL CONSIDERABLE DISTANCES
TO A SOURCE OF IGNITION WHERE THEY MAY IGNITE, FLASHBACK, OR
EXPLODE.
================== Accidental Release Measures ==================
Spill Release Procedures:EXTINGUISH ALL IGNITION SOURCES. DIKE AND
COLLECT MATERIAL FOR DISPOSAL. PREVENT SPILLS FROM ENTERING SEWERS,
STORM DRAINS, WATERWAYS. RECOVER FREE LIQUID. ADD ABSORBENT TO
SPILL AREA. SCOOP UP AND PL ACE IN SUITABLE CONTAINER FOR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY, WELL VENTILATED
AREA AWAY FROM HEAT, SPARKS, OPEN FLAME, OTHER SOURCES OF IGNITION.
KEEP CONTAINERS CLOSED WHEN NOT IN USE.
Other Precautions:BOND AND GROUND ALL EQUIPMENT WHEN TRANSFERRING FROM
ONE VESSEL TO ANOTHER. DO NOT CUT, WELD, OR REUSE EMPTY CONTAINERS.
RETURN THEM TO RECONDITIONING FACILITIES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE SELF-CONTAINED BREATHING APPARATUS IN HIGH
VAPOR CONCENTRATION.
Ventilation:PROVIDE BOTH MECHANICAL (GENERAL) AND LOCAL EXHAUST
VENTILATION AS NEEDED. USE EXPLOSION PROOF SYSTEM.
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
Work Hygienic Practices:WASH AFTER HANDLING AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:>180F,>82C
Vapor Pres:50
Vapor Density:2.8(AIR=1)
Spec Gravity:0.815
Evaporation Rate & Reference:4.0 (BUTYL ACETATE=1)
Solubility in Water:SLIGHT
Appearance and Odor:CLEAR LIQUID. SOLVENT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS OR BASES, OXIDIZING MATERIALS.
Stability Condition to Avoid:ALL SOURCES OF IGNITION.
Hazardous Decomposition Products:COMBUSTION WILL PRODUCE CARBON
MONOXIDE AND CARBON DIOXIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF WASTE IN ACCORDANCE WITH LOCAL, STATE
AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ZEPHYR,MIL-L-2104C,LUBE OIL, GRADE 50
CAGE:LO020
CAGE:LO020
CAGE:60098
============= Composition/Information on Ingredients =============
Ingred Name:PETROLEUM LUBE OIL
===================== Hazards Identification =====================
Effects of Overexposure:AVOID SKIN & EYE CONTACT
======================= First Aid Measures =======================
First Aid:SKIN:WASH W/SOAP & WATER. EYES:IMMEDIATELY FLUSH W/WATER FOR
AT LEAST 15 MINUTES.CALL MD
===================== Fire Fighting Measures =====================
Extinguishing Media:CO*2,DRY CHEMICAL,FOAM
Fire Fighting Procedures:ENCLOSED AREA-AIR SUPPLIED RESCUE EQUIPMENT
Unusual Fire/Explosion Hazard:COOL FIRE EXPOSED CONTAINERS W/WATER.DO
NOT STORE OR MIX W/STRONG OXIDANTS
================== Accidental Release Measures ==================
Spill Release Procedures:RECOVER FREE LIQUID.ADD ABSORBENT TO SPILL
AREA
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS CLOSED.KEEP AWAY FROM
HEAT AND OPEN FLAME.
Other Precautions:AVOID PROLONGED OR REPEATED CONTACT W/SKIN
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF NEEDED,NIOSH/MSHA APPROVED RESPIRATORY
PROTECTION
Ventilation:LOCAL EXHAUST-NEEDED ONLY TO CAPTURE HOT FUMES
NEEDED
Supplemental Safety and Health
CONFORMS TO MIL-L-2104C, GRADE 50
================== Physical/Chemical Properties ==================
HCC:V6
NRC/State Lic Num:NA
Boiling Pt:B.P. Text:400+F
Spec Gravity:0.90
Appearance and Odor:MILD PETROLEUM ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDANTS-LIKE LIQUID CHLORINE & CONCENTRATED OXYGEN
Hazardous Decomposition Products:CARBON MONOXIDE IN THE CASE OF
INCOMPLETE COMBUSTION
Conditions to Avoid Polymerization:MFG STATES NO POLYMERIZATION UNDER
NORMAL OPERATING CNDNS.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATION UNDER CONTROLLED CONDITIONS.DISPOSE
IN ACCORDANCE W/LOCAL,STATE & FEDERAL REGULATIONS
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:RISOGRAPH RA INK, S-574 RED
CAGE:0TMJ3
CAGE:0TMJ3
============= Composition/Information on Ingredients =============
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATES, HYDROTREATED (MILD)
LIGHT PARAFFINIC; (PETROLEUM SOLVENT)
CAS:64742-55-8
RTECS #:PY8036500
Fraction by Wt: <15%
OSHA PEL:5 MG/M3 (MFR)
ACGIH TLV:5 MG/M3 (MFR)
Ingred Name:MINERAL OIL, PETRO DISTILS, ACID-TREATED HEAVY NAPTHENIC
(MILD OR NO SOLV-REFINING OR HYDROTREATMENT); (PETRO SOLVENT)
CAS:64742-18-3
RTECS #:PY8032000
Fraction by Wt: <15%
OSHA PEL:5 MG/M3 (MFR)
ACGIH TLV:5 MG/M3 (MFR)
Ingred Name:GLYCEROL
CAS:56-81-5
RTECS #:MA8050000
OSHA PEL:15 MG/M3 (MIST)
ACGIH TLV:10 MG/M3 (MIST)
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3
Ingred Name:KEROSENE (PETROLEUM), HYDROTREATED; (ALIPHATIC HYDROCARBON)
CAS:64742-47-8
RTECS #:OA5504000
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 60%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:OTHER INGREDIENTS; (OTHERS)
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(ORAL,RAT) 2,000 MG/KG.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:HIGH VAPOR CONCENTRATIONS ARE A LITTLE
IRRITATING TO EYES & RESPIRATORY TRACT. PETROLEUM SOLVENT KNOWN AS
MINERAL OIL IS LISTED CARCINOGENIC IN IARC MONOGRAPHS. CONTACT:EYE
IRRITATION TEST ON RABBITSSHOW MINIMAL IRRITATION. SKIN TESTS
SHOW NO IRRITATION.
Explanation of Carcinogenicity:MILDLY REFINED MINERAL OIL (64742-55-8,
64742-68-3):IARC MONOGRAPHS, SUPP, VOL 7, PG 252, 1987:GROUP 1.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NOT KNOWN.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD IMMEDIATELY . SKIN:FLUSH W/COPIOUS AMOUNTS OF
WATER. CALL MD . EYE:FLUSH W/PLENTY OF WATER FOR AT LEAST 15
MINUTES. INHAL:REMOVE AFFECTED PERSON TO FRESH AIR IMMEDIATELY.
===================== Fire Fighting Measures =====================
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL FOAM OR WATER SPRAY.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . NOT IN PARTICULAR. RISOGRAPH INK IS NOT COMBUSTIBLE.
Unusual Fire/Explosion Hazard:NO UNUSUAL FIRE & EXPLOSION HAZARDS.
================== Accidental Release Measures ==================
Spill Release Procedures:SPILLS SHOULD BE WIPED UP W/CLOTH OR PAPER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NOT IN PARTICULAR. IN ORDER TO KEEP
INK EFFICIENCY, STORE AT TEMPERATURE 41-88F (5-30C).
Other Precautions:NOT IN PARTICULAR. SHOULD INK STAIN HANDS, WASH OFF
IMMEDIATELY W/DETERGENT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN . PREFERABLE IN CASE OF HANDLING A LARGE
AMOUNT.
Ventilation:MECHANICAL (GENERAL): ACCEPTABLE.
Other Protective Equipment:NOT IN PARTICULAR.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Melt/Freeze Pt:M.P/F.P Text:<32F,<0C
Spec Gravity:1-1.02 (H*2O=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:EXTREMELY VISCOUS RED LIQUID W/SLIGHT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products:NONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATION IS PREFERABLE. OBSERVE ALL FEDERAL,
STATE & LOCAL REGULATIONS CONCERNING HEALTH & ENVIRONMENTAL
POLLUTION.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CE-PROCESS BLACK TYPE H,4405-16
CAGE:0UWR2
CAGE:50804
CAGE:26921
CAGE:0UWR2
============= Composition/Information on Ingredients =============
Ingred Name:MINERAL SPIRITS/ISOPARAFFINIC HYDROCARBON SOLVENT
CAS:64475-85-0
RTECS #:PY8240000
Fraction by Wt: >98%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 AS OIL MIST
ACGIH TLV:5 MG/M3 AS OIL MIST
Ingred Name:POLYMERS
Other REC Limits:NONE RECOMMENDED
Ingred Name:PIGMENT
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT) >10,000 MG/KG
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYE, SKIN, RESPIRATORY &
GI TRACTS. ACUTE- NOT EXPECTED TO BE AN EYE IRRITANT. NOT A SKIN
SENSITIZER, NOR A SKIN IRRITANT. LOW ORAL TOXICITY, BUT ASPIRATION
HAZARD. MAY CAUSE CNS DEPRESS ION. MIST MAY CAUSE RESPIRATORY
IRRITATION. INTENTIONAL INHALATION MAY CAUSE CNS TOXICITY. CHRONIC-
UNKNOWN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION
======================= First Aid Measures =======================
First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALED:REMOVE TO FRESH
AIR. PROVIDE CPR/OXYGEN IF NEEDED. EYES:FLUSH WITH WATER FOR 15
MINUTES, HOLDING EYELIDS OPEN. SKIN:WASH WITH SOAP & WATER. ORAL:DO
NOT IN DUCE VOMITING. IF CONSCIOUS, DRINK SEVERAL GLASSES OF WATER.
SEEK IMMEDIATE MEDICAL ATTENTION. IF SPONTANEOUS VOMITING OCCURS,
KEEP HEAD BELOW HIPS.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:102F,39C
Lower Limits:0.8%
Upper Limits:7.0%
Extinguishing Media:WATER FOG, FOAM, DRY CHEMICAL/CARBON DIOXIDE. DON'T
USE DIRECT STREAM OF WATER. PRODUCT WILL FLOAT AND CAN BE
REIGNITED.
Fire Fighting Procedures:DO NOT ENTER ANY ENCLOSED OR CONFINED AREA
WITHOUT PROPER PROTECTIVE EQUIPMENT AND NIOSH-APPROVED AIR-SUPPLIED
BREATHING EQUIPMENT. COOL CONTAINERS WITH WATER.
Unusual Fire/Explosion Hazard:VAPOR IS HEAVIER THAN AIR AND CAN TRAVEL
CONSIDERABLE DISTANCE TO A SOURCE OF IGNITION AND FLASH BACK.
CONTAINERS MAY RUPTURE DUE TO VAPOR PRESSURE BUILDUP.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. ELIMINATE SOURCES
OF IGNITION. VENTILATE AREA. PICK UP SPILL WITH NON-FLAMMABLE
ABSORBENT SUCH AS SAND OR VERMICULITE. PREVENT LIQUID FROM ENTERING
SEWERS OR WATERWAYS.
Neutralizing Agent:NOT RELEVANT
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, VENTILATED AREA, AWAY
FROM HEAT, FLAMES, SPARKS, HOT SURFACES & INCOMPATIBLE MATERIALS.
KEEP CONTAINER TIGHTLY CLOSED.
Other Precautions:DO NOT, CUT, DRILL, GRING, WELD OR DO SIMILAR
OPERATIONS TO "EMPTY" CONTAINERS. THEY CONTAIN FLAMMABLE RESIDUE.
USE PROPER BONDING AND GROUNDING PROCEDURES DURING TRANSFER
OPERATIONS. KEEP OUT OF REAC H OF CHILDREN. DO NOT BREAHTE
VAPOR/MIST
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED WHEN USED AS INTENDED WITH XEROX
ENGINEERING SYSTEMS PRODUCTS.
Ventilation:USE EXPLOSION-PROOF VENTILATION EQUIPMENT TO CONTROL VAPOR
CONCENTRATIONS.
Other Protective Equipment:SAFETY SHOWER AND EYE WASH FOUNTAIN SHOULD
BE LOCATED NEARBY. WEAR APPROPRIATE PROTECTIVE CLOTHING FOR RISK OF
EXPOSURE.
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. WASH THOROUGHLY BEFORE EATING,
DRINKING/SMOKING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F4
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:320F - 356F
Vapor Pres:1 @ 68F
Vapor Density:5.0
Spec Gravity:0.77
VOC Pounds/Gallon:730
Evaporation Rate & Reference:0.3 (N-BUTYL ACETATE=1)
Solubility in Water:IMMISCIBLE
Appearance and Odor:BLACK LIQUID - SLIGHT ODOR
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS SUCH AS LIQUID CHLORINE, CONCENTRATED OXYGEN,
SODIUM HYPOCHLORITE OR CALCIUM HYPOCHLORITE
Stability Condition to Avoid:HEAT, FLAMES, SPARKS, HOT SURFACES
Hazardous Decomposition Products:FUMES, SMOKE, CARBON MONOXIDE, CARBON
DIOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN AN APPROVED INCINERATOR OR
CONTRACT WITH LICENSED CHEMICAL WASTE DISPOSAL SERVICE. DISCHARGE,
TREATMENT OR DISPOSAL IS SUBJECT TO FEDERAL, STATE OR LOCAL LAWS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:QUINGAS 2 HIGH METHANE, COMPRESSED GAS
Kit Part:Y
CAGE:23972
CAGE:73200
CAGE:23972
============= Composition/Information on Ingredients =============
Ingred Name:METHANE
CAS:74-82-8
RTECS #:PA1490000
Fraction by Wt: 25%
ACGIH TLV:SIMPLE ASPHYXIANT
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE ASPHYXIATION W/RAPID
RESPIRATION & PULSE, COLLAPSE, DEEP COMA & DEATH. SKIN: MAY CAUSE
FROSTBITE & DEVELOP BLISTERS. EYES: FROSTBITE & BLURRED VISION.
INGESTION: FROSTBITE MAY DAMAGE THE LI PS, MOUTH & MUCOUS
MEMBRANES.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:ASPHYXIATION, UNCONSCIOUSNESS, RAPID
RESPIRATION & PULSE, AIR HUNGER, DIZZINESS, REDUCED AWARENESS,
TIGHTNESS IN THE HEAD, TINGLING SENSATIONS, INCOORDINATION, FAULTY
JUDGEMENT, EMOTIONAL INSTABILITY, RAPID FATIGUE, NAUSEA, VOMITING,
COLLAPSE, CONVULSIONS, COMA, REDNESS, PAIN, NUMBNESS, BLURRED
VISION
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR IMMEDIATELY. IF BREATHING HAS
STOPPED, GIVE CPR. MAINTAIN AIRWAY & BLOOD PRESSURE & GIVE OXGYGEN.
KEEP WARM & AT REST. TREAT SYMPTOMATICALLY/SUPPORTIVELY. OXYGEN
SHOULD BE GIVEN BY QUALIFIED PERSONNEL. SKIN:WASH W/WARM WATER AT
TEMP OF 107F. EYES: WASH W/LARGE AMOUNTS OF WARM WATER FOR 15-20
MINS. OBTAIN MEDICAL ATTENTION IN ALL CASES. NO SPECIFIC ANTIDOTE.
===================== Fire Fighting Measures =====================
Flash Point:-369F
Lower Limits:5
Upper Limits:15
Extinguishing Media:DRY CHEMICAL, CO2/HALON. FOR LARGE: WATER SPRAY,
FOG/STANDARD FOAM.
Fire Fighting Procedures:MOVE CONTAINER FROM AREA. STAY AWAY FROM
STORAGE TANK ENDS. FOR MASSIVE FIRE, USE UNMANNED HOSE
HOLDER/MONITOR NOZZLES/W/DRAW FROM AREA & LET BURN. (SEE SUPP)
Unusual Fire/Explosion Hazard:VAPOR-AIR MIXTURES ARE EXPLOSIVE
>FLASHPOINT. CYLINDER MAY EXPLODE IN HEAT/FIRE. DUE TO
ELECTROCONDUCTIVITY, FLOW/AGITATION MAY GENERATE SPARKS
W/IGNITION.(SUPP
================== Accidental Release Measures ==================
Spill Release Procedures:SHUT OFF IGNITION SOURCES. STOP LEAK SAFELY
W/O RISK. USE WATER SPRAY TO REDUCE VAPORS. ISOLATE AREA UNTIL GAS
HAS DISPERSED. NO SMOKING/FLAMES/FLARES. KEEP PEOPLE AWAY. ISOLATE
HAZARD AREA & DENY ENT Y. VENTILATE CLOSED SPACES BEFORE ENTERING.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM INCOMPATIBLE
SUBSTANCES. AVOID CONTACT W/HEAT/SPARKS/FLAMES/OTHER IGNITION
SOURCES.
Other Precautions:CONTENTS UNDER PRESSURE. CONTAINERS MAY RUPTURE
VIOLENTLY & TRAVEL A CONSIDERABLE DISTANCE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE ANY SUPPLIED-AIR RESPIRATOR OPERATED IN
PRESSURE-DEMAND/OTHER POSITIVE PRESSURE MODE. ANY SELF CONTAINED
BREATHING APPARATUS. FOR FIREFIGHTING: A SCBA W/FULL FACEPIECE
OPERATED IN PRESSURE-DEMAND/ POSITIVE PRESSURE MODE.
Ventilation:GENERAL DILUTION VENTILATION
Other Protective Equipment:EYEWASH FOUNTAIN, QUICK DRENCH SHOWER
Work Hygienic Practices:CONTACT LENSES SHOULDN'T BE WORN.
Supplemental Safety and Health
FIRE PROC CONT'D: W/DRAW IMMEDIATELY IF RISING SOUND FROM VENTING
SAFETY DEVICE/ANY DISCOLORATION OF STORAGE TANK FROM FIRE. LET
STORAGE VESSEL BURN/EXTINGUISH IF FLOW CAN BE STOPPED. COOL
CONTAINERSW/FLOODING AMOUNTS OF WATER, APPLY FROMA FAR DISTANCE.
AVOID BREATHING VAPORS, KEEP UPWIND. EVACUATE-RADIUS OF 1500 FT.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:-260F
Melt/Freeze Pt:M.P/F.P Text:-296F
Vapor Pres:76
Vapor Density:0.555
Spec Gravity:0.717
Solubility in Water:3.5%
Appearance and Odor:COLORLESS, TASTELESS GAS W/NO ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
BROMINE, CHLORINE, CHLORINE DIOXIDE, DIOXYGEN DIFLUORIDE, FLUORINE,
INTERHALOGENS, OXIDIZERS, OXYGEN DIFLUORIDE, OXYGEN
Stability Condition to Avoid:HEAT, SPARKS, FLAMES, STATIC ELECTRICITY &
OTHER IGNTION SOURCES
Hazardous Decomposition Products:OXIDES OF CARBON
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS. UN1971. EPA HAZARDOUS WASTE NUMBER D001.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:LUBRIZOL 1191
CAGE:GO887
CAGE:05238
CAGE:GO887
============= Composition/Information on Ingredients =============
Ingred Name:ACCORDING TO MFG THERE ARE NO HAZARDOUS INGREDIENTS IN THIS
PRODUCT ACCORDING TO OSHA 29CFR 1910.1200.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL:>5000MG/KG (RAT)
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SEE SIGNS AND SYMPTOMS OF OVEREXPOSURE
SECTION
Explanation of Carcinogenicity:N/A
Effects of Overexposure:EYE:NOT EXPECTED TO CAUSE EYE IRRITATION. BASED
ON ACTUAL DATA. SKIN:NOT EXPECTED TO CAUSE SKIN IRRITATION. BASED
ON ACTUAL DATA. OTHER:NONE.
Medical Cond Aggravated by Exposure:N/K
======================= First Aid Measures =======================
First Aid:EYE:IMMED FLUSH W/LGE AMTS OF WATER FOR AT LEAST 15
MIN.SKIN:WASH WITH SOAP & WATER. INHALATION:REMOVE TO FRESH
AIR.SUPPORT BREATHING(GIVE O*2/ARTIFICIAL RESPIRATION).
INGESTION:CALL A PHYSICIAN . DO NOT INDUCE
VOMITING.ADDITIONAL:NONE.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:309.2F/154C
Lower Limits:NT DETERMINE
Upper Limits:NT DETERMINE
Extinguishing Media:CO*2, DRY CHEMICAL, FOAM; WATER SPRAY, WATER FOG
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT
Unusual Fire/Explosion Hazard:TOXIC FUMES MAY BE EVOLVED ON BURNING OR
EXPOSURE TO HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:PREVENT ENTRY INTO SEWERS AND WATERWAYS.PICK
UP FREE LIQUID FOR RECYCLE/DISPOSAL.ABSORB SMALL AMOUNTS ON INERT
MATERIAL FOR DISPOSAL.
Neutralizing Agent:N/K
======================Handling and Storage ======================
Handling and Storage Precautions:N/K
Other Precautions:REMOVE CONTAMINATED CLOTHING AND LAUNDER BEFORE
REUSE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN
Ventilation:MECHANICAL VENTILATION RECOMMENDED.
Other Protective Equipment:NONE
Work Hygienic Practices:SEE OTHER PRECAUTIONS.
Supplemental Safety and Health
RT OF ENTRY:ACCORDING TO MFG, TLV OF PRODUCT IS NOT ESTABLISHED. OIL
MIST=5MG/M3.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:N/K
Melt/Freeze Pt:M.P/F.P Text:N/K
Decomp Temp:Decomp Text:N/K
Vapor Pres:NOT SETERM
Vapor Density:NOT DETERM
Spec Gravity:0.990 AT 15.6C
pH:N/DETE
Evaporation Rate & Reference:NOT DETERMINED
Solubility in Water:INSOLUABLE
Appearance and Odor:DARK COLORLES LIQUID
Percent Volatiles by Volume:N/DETE
Corrosion Rate:
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS
Stability Condition to Avoid:N/K
Hazardous Decomposition Products:OXIDES OF
CARBON,SULFUR,NITROGEN,PHOSPHORUS,CALCIUM;ZINC AND HYDROGEN
SULFIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:IF DISPOSED OF,THIS MATERIAL MAY BE HAZARDOUS
FOR DISPOSAL UNDER RCRA DUE TO REACTIVITY.DISPOSAL SHOULD BE IN
COMPLIANCE WITH FEDERAL, STATE AND LOCAL LAWS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:GELATIN FROM COLD WATER FISH SKIN, G7765
CAGE:21076
CAGE:21076
============= Composition/Information on Ingredients =============
Ingred Name:GELATIN
CAS:9000-70-8
RTECS #:LX8580000
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE EFFECTS: MAY BE HARMFUL BY
INHALATION, INGESTION OR SKIN ABSORPTION. MAY CAUSE IRRITATION. THE
TOXICOLOGICAL PROPERTIES HAVE NOT BEEN THOROUGHLY INVESTIGATED.
ALSO, SEE TOXICOLOGICAL INFORMATION .
Effects of Overexposure:SEE HEALTH HAZARDS.
======================= First Aid Measures =======================
First Aid:INGESTION: WASH OUT MOUTH WITH WATER PROVIDED PERSON IS
CONSCIOUS. CALL A PHYSICIAN. SKIN: IN CASE OF SKIN CONTACT, FLUSH
WITH COPIOUS AMOUNTS OF WATER FOR AT LEAST 15 MINUTES. REMOVE
CONTAMINATED CLO THING AND SHOES. CALL A PHYSICIAN. INHALATION: IF
INHALED, REMOVE TO FRESH AIR. IF BREATHING BECOMES DIFFICULT, CALL
A PHYSICIAN. EYES: IN CASE OF CONTACT WITH EYES, FLUSH WITH COPIOUS
AMOUNTS OF WATE R FOR AT LEAST 15 MINUTES. ASSURE ADEQUATE FLUSHING
BY SEPARATING THE EYELIDS WITH FINGERS. CALL A PHYSICIAN.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER SPRAY. CARBON DIOXIDE, DRY CHEMICAL POWDER OR
APPROPRIATE FOAM.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT TO PREVENT CONTACT WITH SKIN AND EYES.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. ABSORB ON SAND OR
VERMICULITE AND PLACE IN CLOSED CONTAINERS FOR DISPOSAL. VENTILATE
AREA AND WASH SPILL SITE AFTER MATERIAL PICKUP IS COMPLETE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR APPROPRIATE NIOSH APPROVED RESPIRATOR.
Ventilation:MECHANICAL EXHAUST REQUIRED.
Other Protective Equipment:EYE WASH AND DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA . WEAR OTHER PROTECTIVE CLOTHING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Solubility in Water:SOLUBLE.
Appearance and Odor:LIQUID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE.
=================== Toxicological Information===================
Toxicological Information:RTECS #: LX8580000. GELATINS. TARGET ORGAN
DATA: SPECIFIC DEVELOPMENTAL ABNORMALITIES (UROGENITAL SYSTEM)
EFFECTS ON NEWBORN (GROWTH STATISTICS). ONLY SELECTED REGISTRY OF
TOXIC EFFECTS OF CHEMICAL SU BSTANCES (RTECS) DATA IS PRESENTED
HERE. SEE ACTUAL ENTRY IN RTECS FOR COMPLETE INFORMATION.
===================== Ecological Information =====================
Ecological:DATA NOT YET AVAILABLE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISSOLVE OR MIX THE MATERIAL WITH A COMBUSTIBLE
SOLVENT AND BURN IN A CHEMICAL INCINERATOR EQUIPPED WITH AN
AFTERBURNER AND SCRUBBER. OBSERVE ALL FEDERAL, STATE AND LOCAL
ENVIRONMENTAL REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:CONTACT SIGMA CHEMICAL COMPANY FOR TRANSPORTATION
INFORMATION.
===================== Regulatory Information =====================
Federal Regulatory Information:REVIEWS, STANDARDS AND REGULATIONS:
OEL=MAK. NOSH 1974: HZD 34715; NIS 81; TNF 9213; NOS 59, TEN 64210.
NOES 1983: HZD X8717; NIS 2; TNF 64; NOS 6; TNE 665; TFE 314. NOES
1983: HZD 34715; NIS 92; TNF 13735; NOS 89; TNE 169507; TFE 72931.
EPA TSCA SECTION 8(B) CHEMICAL INVENTORY.
State Regulatory Information:
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:31060 TAXO ARABINOSE DISCS
Preparer's Name:DALI M AREN
CAGE:06531
CAGE:05545
CAGE:06531
============= Composition/Information on Ingredients =============
Ingred Name:NON-HAZARDOUS FOR INGREDIENTS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Explanation of Carcinogenicity:NONE
======================= First Aid Measures =======================
First Aid:OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:IF PRODUCT BECOMES INVOLVED IN A FIRE SITUATION ANY
EXTINGUISHING MEDIA USED DURING FIRE FIGHTING WILL BE COMPATIBLE.
================== Accidental Release Measures ==================
Spill Release Procedures:MAY BE SWEPT UP & DISPOSED OF W/NORMAL LAB
TRASH.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED UNDER NORMAL PRODUCT USAGE.
Ventilation:NONE REQUIRED UNDER NORMAL PRODUCT USAGE.
Other Protective Equipment:NONE REQUIRED UNDER NORMAL PRODUCT USAGE.
Work Hygienic Practices:GOOD PERSONAL HYGIENE SHOULD BE PRACTICED.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Solubility in Water:INSOLUBLE
Appearance and Odor:PAPER DISCS OF VARIABLE COLOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:MAY BE DISPOSED OF W/NORMAL LAB TRASH.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:2126-00 ACID REAGENT
CAGE:91224
CAGE:91224
============= Composition/Information on Ingredients =============
Ingred Name:POTASSIUM PYROSULFATE
CAS:7790-62-7
Fraction by Wt: 100%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PRODUCT IS CORROSIVE TO ALL MOIST BODY
TISSUES,(WET SKIN), AND IS TOXIC DUE TO ITS CORROSIVITY.
Effects of Overexposure:BURNS TO MOIST AREAS OF BODY. I.E. EYES,MUCOUS
MEMBRANES,WET SKIN.
Medical Cond Aggravated by Exposure:NONE LISTED.
======================= First Aid Measures =======================
First Aid:EYE/SKIN:FLUSH WITH WATER. REMOVE CONTAMINATED CLOTHING. GET
MEDICAL ATTENTION. INHALE:REMOVE TO FRESH AIR. GIVE OXYGEN OR
ARTIFICIAL RESPIRATION AS NEEDED. CALL PHYSICIAN. INGEST:DO NOT
INDUCE VOMITI NG. GIVE LARGE AMOUNT OF MILK OR WATER.GET MEDICAL
ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:DRY CHEMICAL,FOAM,CARBON DIOXIDE.
Fire Fighting Procedures:USE SELF CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:MAY EMIT TOXIC FUMES AT FIRE CONDITIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:NEUTRALIZE SPILL. ADD WATER TO FORM SLURRY.
Neutralizing Agent:SODIUM BICARBONATE OR 50/50 SODA ASH AND LIME.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL DRY AREA, AWAY FROM
ALKALIS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY NEEDED. USE NIOSH RESPIRATOR OR
SUPPLIED AIR RESPIRATOR IF EXPOSED ABOVE TLV.FOR NUISANCE DUST.
Ventilation:USE HOOD OR OTHER LOCAL EXHAUST TO MAINTAIN EXPOSURE BELOW
TLV FOR NUISANCE DUST.
Other Protective Equipment:EYE WASH,SAFETY SHOWER, LAB COAT OR APRON.
Work Hygienic Practices:USE NORMAL CHEMICAL HYGIENE PRACTICES.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:C1
Melt/Freeze Pt:M.P/F.P Text:617F/325C
Spec Gravity:2.25
Solubility in Water:SOLUBLE
Appearance and Odor:SOLID WHITE POWDER,NO ODOR. PH AQUEOUS SOLUTION IS
ACID.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALKALIS
Stability Condition to Avoid:MOISTURE
Hazardous Decomposition Products:OXIDES OF SULFUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE I/A/W FEDERAL,STATE,LOCAL REGULATIONS.
MFR SUGGESTS FLUSH NEUTRALIZED MATERIAL TO DRAIN WITH EXCESS WATER.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:DELTON OPAQUE UNIVERSAL 2694
CAGE:FO540
CAGE:64397
CAGE:FO540
============= Composition/Information on Ingredients =============
Ingred Name:SILICA AMORPHOUS HYDRATED, SILICEOUS EARTH, FUMED
SILICA,COLLOIDAL SILICA, AMORPHOUS SILICA
CAS:112945-52-5
RTECS #:VV7310000
Fraction by Wt: 11%
Other REC Limits:20 MPPCF
OSHA PEL:80 MG/CUM (%SIO2+2)
Ingred Name:AROMATIC & ALILPHATIC DIMETHACRYLATE MONOMERS
Fraction by Wt: 98.54%
Ingred Name:2,6-DI-TERT-BUTYL-P-CRESOL
CAS:128-37-0
RTECS #:GO7875000
Fraction by Wt: 0.15%
OSHA PEL:10 MG/M3
ACGIH TLV:10 MG/M3; 9192
Ingred Name:ANILINE (SARA III)
CAS:62-53-3
RTECS #:BW6650000
Fraction by Wt: 2.2%
Other REC Limits:2 PPM (SKIN)
OSHA PEL:S, 5 PPM
ACGIH TLV:S, 2 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TITANIUM DIOXIDE
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 3.0%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL RAT): >5000 MG/KG
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION & DISCOMFORT. SKIN:
REPEATED CONTACT MAY CAUSE REDDENING & IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES: IRRITATION & DISCOMFORT. SKIN: REPEATED
CONTACT MAY CAUSE REDDENING & IRRITATION.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/COPIOUS QUANTITIES OF WATER FOR 15 MINS. SEEK
MED ATT. SKIN: WASH W/SOAP & WATER.
===================== Fire Fighting Measures =====================
Extinguishing Media:DRY CHEMICAL, FOAM, CO2
Fire Fighting Procedures:USE PROTECTIVE GEAR. USE WATER FOG TO COOL
LARGE CONTAINERS EXPOSED TO FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB ONTO VERMICULITE & CLAY. SCOOP UP &
DISPOSE INTO ACCEPTABLE CONTAINERS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM IGNITION SOURCES.
PROTECT FROM HEAT. KEEP CONTAINERS CLOSED WHEN NOT IN USE. AVOID
CONTACT W/SKIN.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED
Other Protective Equipment:NONE
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Spec Gravity:1.2
Appearance and Odor:TRANSPARENT LIGHT AMBER LIQUID, CHARACTERISTIC
METHACRYLATE ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:ELEVATED TEMPERATURES, IGNITION SOURCES,
HEAT
Conditions to Avoid Polymerization:TERTIARY AMINE BASED COMPOUNDS
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL REGULATIONS FOR
RELATIVELY NONTOXIC ORGANICS. AVOID CONDITIONS WHICH MAY RESULT IN
DISPERSION TO STREAMS & WATERWAYS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:KEEGO
CAGE:9T403
CAGE:59327
CAGE:9T403
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM METASILICATE
CAS:6834-92-0
RTECS #:VV9275000
Fraction by Wt: <40%
===================== Hazards Identification =====================
Effects of Overexposure:EYES: SEVERE IRRIT/BURNS MAY CAUSE
REDDNESS,PAIN & POSS REVERSIBLE CORNEAL DAMAGE. (SEE SUPP DATA)
======================= First Aid Measures =======================
First Aid:EYES: FLUSH IMMED W/H*20 MINIMUM 15 MIN. GET IMMED MED ATTN.
SKIN: FLUSH W/H*2O. IF IRRIT DEVELOPS,CALL A PHYS. INGEST: DRINK
LRG AMTS H*2O/MILK. DONT INDUCE VOMIT. GET MED ATTN. INHAL: REMOVE
TO FRES H AIR. IF BREATHING DIFF PERSISTS, GET MED ATTN.
===================== Fire Fighting Measures =====================
Flash Point:NOT COMBUSTIBLE
Extinguishing Media:WATER,WATER FOG
Fire Fighting Procedures:USE SCBA & TURN-OUT GEAR
Unusual Fire/Explosion Hazard:MAKES ALKALINE SOLUTION WHEN DISSOLVED IN
WATER.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP & PLACE IN A METAL CONTAINER. BURY IN
AN APPROVED CHEMICAL LANDFILL. RINSE AFFECTED AREAS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL,DRY AREA. DONT STORE
W/ACIDS. KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Ventilation:MECHANICAL TO CONTROL DUST OR MIST.
Other Protective Equipment:CLOTHING TO PREVENT SKIN CONTACT.
Supplemental Safety and Health
SPEC GRAV: 60.1 LBS/CUFT. EFFECTS OF OVEREXP: SKIN- SEVERELY IRRIT.
INGEST- POSS PAIN,NAUSEA & GASTRIC DISTRESS. INHAL- IRRIT TO
NOSE,THROAT & LUNG TISSUE.
================== Physical/Chemical Properties ==================
Solubility in Water:COMPLETE
Appearance and Odor:WHITE,GRANULAR POWDER
Percent Volatiles by Volume:NONE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID MIXING W/ACIDS.
Stability Condition to Avoid:DONT MIX W/ACIDS. WILL RELEASE HEAT.
Hazardous Decomposition Products:NONE KNOWN
==================== Disposal Considerations ====================
Waste Disposal Methods:MAKES ALKALINE SOLUTIONS W/WATER. MAY REQUIRE
NEUTRALIZATION W/DILUTE ACIDS TO A SPECIFIC PH BEFORE DISCHARGE TO
A SANITARY SEWER. WASTE DISPOSAL MUST BE IAW FEDERAL,STATE & LOCAL
CODES.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CLEANER CONCENTRATE
Preparer's Name:GEORGE A MONEY
CAGE:NO567
CAGE:NO567
============= Composition/Information on Ingredients =============
Ingred Name:SURFACTANT BLEND
Other REC Limits:NONE RECOMMENDED
Ingred Name:VOC: 0
RTECS #:9999999VO
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NONE KNOWN
Effects of Overexposure:MAY DRY SKIN
Medical Cond Aggravated by Exposure:NONE KNOWN
======================= First Aid Measures =======================
First Aid:RINSE SKIN WITH WATER AND WASH CLOTHING.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:>400F,>204C
Autoignition Temp:Autoignition Temp Text:220 F
Extinguishing Media:WATER / THIS PRODUCT EXTINGUISHES FIRE
Fire Fighting Procedures:NONE APPLICABLE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB WITH ABSORBENT MATERIAL AND PLACE IN
APPROPRIATE CONTAINER.
Neutralizing Agent:WATER
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN SHELTERED AREA AWAY FROM
EXCESS HEAT OR FLAME.
Other Precautions:NONE SPECIFIED
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR RESPIRATOR IN CONFINED AREAS.
Ventilation:NONE REQUIRED
Other Protective Equipment:NONE
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:120F,49C
Melt/Freeze Pt:M.P/F.P Text:10F,-12C
Decomp Temp:Decomp Text:210F,99C
Vapor Pres:WATER
Spec Gravity:1.12 (WATER=1)
pH:8.5-9.
Viscosity:100-55 SUBOLD
Evaporation Rate & Reference:WATER
Solubility in Water:100%
Appearance and Odor:LIGHT BLUE WITH A BLAND ODOR
Percent Volatiles by Volume:0
Corrosion Rate:NONE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
BLEACH AND STRONG OXIDIZERS
Stability Condition to Avoid:DO NOT HEAT LIQUID TO A TEMPERATURE IN
EXCESS OF 120F.
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE,
AND FEDERAL ENVIRONMENTAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:8R7724, FUSER OIL, FUSER LUBRICANT, FUSER (SUPDAT)
CAGE:0E6G9
CAGE:0E6G9
CAGE:26921
============= Composition/Information on Ingredients =============
Ingred Name:POLYDIMETHYLSILOXANE
CAS:63148-62-9
Fraction by Wt: 100%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50: (ORAL, RAT) >35 G/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE MINIMAL IRRITATION OF
RESPIRATORY PASSAGES ON CONTINUOUS EXPOSURE TO HIGH CONCENTRATIONS.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE WHEN USED AS DESCRIBED BY
PRODUCT LITERATURE.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR AT LEAST 15 MINUTES. SKIN: WASH
WITH SOAP AND WATER. INHALATION: REMOVE FROM EXPOSURE. INGESTION:
DILUTE STOMACH CONTENTS WITH SEVERAL GLASSES OF WATER.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:>500F,>260C
Extinguishing Media:FOAM, CARBON DIOXIDE, WATER SPRAY.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:SOAK UP WITH AN ABSORBENT MATERIAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE REASONABLE CARE AND CAUTION. CLEAN
UP SPILLS COMPLETELY AS RESIDUE IS SLIPPERY.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED WHEN USED AS INTENDED IN XEROX
EQUIPMENT. USE NIOSH APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE
OF CONCERN .
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
MFR'S TRADE NAME/PART NO: WEB, FUSER WICK, FUSER ROLL.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:300F,149C
Vapor Pres:<5
Spec Gravity:0.98 (H*2O=1)
VOC Pounds/Gallon:980
Evaporation Rate & Reference:<1 (ETHER=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR LIQUID; SLIGHT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING MATERIALS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:SILICONE DIOXIDE, CARBON DIOXIDE AND
TRACES OF INCOMPLETELY BURNED CARBON PRODUCTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:ABSORB LIQUID ON VERMICULITE OR OTHER ABSORBENT
MATERIAL. DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS. BIODEGRADATION/NON-BIODEGRADABLE, BIOACCUMULATION/NO
EVIDENCE OF ACCUMULAT ION.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:METADI AEROSOL SPRAY, 40-6270
Preparer's Name:THOMAS R. DERAM
CAGE:09410
CAGE:09410
============= Composition/Information on Ingredients =============
Ingred Name:HEXYLENE GLYCOL
CAS:107-41-5
RTECS #:SA0810000
Fraction by Wt: <10%
OSHA PEL:C 25 PPM
ACGIH TLV:C 25 PPM; 9192
Ingred Name:ISOPROPYL ALCOHOL (SARA III)
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 10-30%
OSHA PEL:400 PPM/500 STEL
ACGIH TLV:400 PPM/500STEL;9192
Ingred Name:FLUORO CHLORO CARBON PROPELLANT(CONSISTING OF INGREDIENTS 4
& 5 OF A 50/50 MIXTURE)
Fraction by Wt: >60%
Other REC Limits:1000 PPM (MFR)
Ingred Name:P-11
CAS:1175-69-4
Ingred Name:DICHLORODIFLUOROMETHANE (SARA III)
CAS:75-71-8
RTECS #:PA8200000
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ozone Depleting Chemical:1
Ingred Name:DIAMOND ABRASIVE VARIOUS GRADES
Fraction by Wt: 5%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:DEFATTING WITH PROLONGED CONTACT, SEE
SIGNS & SYMPTOMS
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:EYES/SKIN:MILD IRRIT.INHAL: DROWSINESS,
DIZZINESS, NASAL AND RESP IRRIT. INGEST: NAUSEA, VOMITING,
DIARRHEA, ABDOMINAL IRRIT.
Medical Cond Aggravated by Exposure:OVER EXPOSURE MAY AGGRAVATE
ASTHMATIC CONDITIONS.
======================= First Aid Measures =======================
First Aid:SKIN:WASH THOROUGHLY WITH SOAP AND WATER. INHAL:MOVE
INDIVIDUAL TO FRESH AIR. SUPPORT BREATHING (GIVE O*2 ARTF/RESP) .
EYES:FLUSH THOROUGHLY WITH WATER FOR AT LEAST 15 MIN. INJEST:DILUTE
WITH W ATER, INDUCE VOMITING.
===================== Fire Fighting Measures =====================
Flash Point:COMBUSTIBLE
Extinguishing Media:WATER,CARBON DIOXIDE,FOAM
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED PRESSURE DEMAND SCBA
AND FULL PROTECTIVE EQUIPMENT
Unusual Fire/Explosion Hazard:CONTR CONTAINS LIQ COMPRESSED GAS UNDER
PRESS, PLUS MINOR AMOUNT OF FLAM SOLVENT.THERMAL DECOMP PRODUCTS
MAY INCLUDE CHLORIDES,FLUORIDES AND PHOSGENE
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA - ABSORB LIQUID ON SUITABLE
INERT ABSORBING MATERIAL AND DISPOSE IN SUITABLE WASTE CONTAINER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:PRODUCT CONTAINS LIQUEFIED GAS UNDER
PRESSURE. AVOID TEMPS ABOVE 125F.
Other Precautions:DO NOT SPRAY NEAR EYES. NO SMOKING IN AREA OF USE. DO
NOT USE IN GENERAL VICINITY OF ARC WELDING,OPEN FLAMES OR HOT
SURFACES.HEAT &/OR UV RADIATION MAY CAUSE FORMATION OF
CHLORIDES,FLUORIDES OR PHOSGE NE .
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR NIOSH/MSHA APPROVED RESPIRATOR IN PRESENCE
OF HIGH VAPOR CONCENTRATION
Ventilation:LOCAL EXHAST TO MAINTAIN EXPOSURE BELOW TLV IN INGRED.
SECTION
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:GOOD PERSONAL HYGIENE TO BE FOLLOWED AT ALL
TIMES.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:-6F,-21C
Melt/Freeze Pt:M.P/F.P Text:90%
Vapor Pres:1900 @ 70F
Vapor Density:3
Spec Gravity:>1
Evaporation Rate & Reference:>1(BUTYL ACETATE=1)
Solubility in Water:PARTIALLY SOLUBLE
Appearance and Odor:PLEASANT ODOR,VARIUOS COLORS ACCORDING TO DIAMOND
GRADE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CONTACT WITH STRONG MINERAL ACIDS, STRONG OXIDIZING AGENTS, RUBBER AND
SOME PLASTICS
Stability Condition to Avoid:OPEN FLAMES OR HIGH TEMPS ABOVE 125F IN
STORAGE CANS
Hazardous Decomposition Products:HIGH TEMP (FLAME) DECOMP OF PROPELLANT
ONLY MAY FORM HYDROCHLORIC AND HYDROFLUORIC ACIDS. POSSIBLY
PHOSGENE.
==================== Disposal Considerations ====================
Waste Disposal Methods:FLUSH WASTE MATERIAL WITHOUT PROPELLANT DOWN
DRAIN.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:X-5898 TT-P-1952B WHITE LATEX TRAFFIC LINE PAINT
Preparer's Name:NORMA HABEEK
CAGE:6F266
CAGE:6F266
============= Composition/Information on Ingredients =============
Ingred Name:ETHYLENE GLYCOL (SARA III)
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: 1.94%
Other REC Limits:NONE RECOMMENDED
ACGIH TLV:C 50 PPM,VAPOR; 9394
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:TEXANOL OR PROPIONIC ACID,2-METHYL,MONOESTER WITH
2,2,4-TRIMETHYL-1,3-PENTANEDIOL
CAS:25265-77-4
RTECS #:UF6000000
Fraction by Wt: 0.86%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:100 PPM (92/93)
Ingred Name:VOLATILE ORGANIC COMPOUND: 77 GRAMS/LITERS (LESS WATER)
RTECS #:9999999VO
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: PROLONGED INHALATION IN A
CONFINED SPACES MAY CAUSE MUCOUS MEMBRANE IRRITATION, CNS EFFECTS.
CONTACT WITH SKIN AND EYES MAY CAUSE IRRITATION. INCIDENTAL
INGESTION IS NOT LIKELY TO CAUSE INJURY; HOWEVER INGESTION OF
LARGE AMOUNTS COULD CAUSE SERIOUS INJURY. CHRONIC: NONE SPECIFIED
BY MANUFACTURER.
Explanation of Carcinogenicity:NO INGREDIENT OF A CONCENTRATION OF 0.1%
OR GREATER IS NOT LISTED AS A CARCINOGEN OR SUSPECTED CARCINOGEN.
Effects of Overexposure:INHALED: DIZZINESS, HEADACHE, SHORTNESS OF
BREATH. EYES: REDNESS, TEARING, DISCOMMFORT. SKIN: REDNESS,
DISCOMFORT.
Medical Cond Aggravated by Exposure:NONE, WHEN USED IN ACCORDANCE WITH
SAFE HANDLING INSTRUCTIONS.
======================= First Aid Measures =======================
First Aid:INHALED-REMOVE TO FRESH AIR. IF RESPIRATORY SYMPTOMS DEVELOP,
GET MEDICAL ATTENTION. EYES-FLUSH WITH WATER FOR 15 MINUTES, HOLD
LIDS OPEN. GET EMERGENCY MEDICAL TREATMENT. SKIN-RINSE WITH WATER,
THEN WASH WITH SOAP & WATER. REMOVE CONTAMINATED CLOTHES.
INGESTED-OBTAIN EMERGENCY MEDICAL TREATMENT IMMEDIATELY. TARGET
ORGANS: SKIN,EYES,LUNG.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:NONFLAMMABLE
Extinguishing Media:FOAM, DRY CHEMICAL, WATER OR WATER FOG.
Fire Fighting Procedures:FIREFIGHTERS AND OTHERS EXPOSED TO PRODUCTS OF
COMBUSTION SHOULD WEAR SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:WILL NOT BURN, CLOSED CONTAINERS MAY
BURST IF EXPOSED TO EXTREME HETA. WATER MAY BE USED TO COOL &
PROTECT EXPOSED CONTAINERS.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. ABSORB WITH INERT MATERIAL &
PLACE IN A CONTAINER FOR LATER DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID TEMPERATURES BELOW 40F. KEEP
FROM FREEZING. STORE CONTAINERS WITH LIDS TIGHTLY CLOSED &
APPROPRIATELY LABELLED.
Other Precautions:KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF PERSONAL EXPOSURE CANNOT BE CONTROLLED BY
VENTILATION; USE NIOSH/MSHA APPROVED RESPIRATOR WITH ORGANIC VAPOR
CARTRIDGE OR SCBA, AS REQUIRED. USE RESPIRATORY PROTECTION IAW
MANUFACTURER'S RECOMMENDA TIONS & 29 CFR 1910.134.
Ventilation:LOCAL EXHAUST PREFERABLE. GENERAL EXHAUST ACCEPTABLE IF
EXPOSURE MAINTAINED BELOW TLV/PEL.
Other Protective Equipment:EYE WASH STATION & SAFETY SHOWER.
Work Hygienic Practices:KEEP WORK AREA CLEAN & FREE FROM SPILLS/LEAKS.
WASH HANDS AFTER USE & BEFOR EATING, DRINKING, SMOKING.
Supplemental Safety and Health
NOTE: THIS PRODUCT CONTAINS NO MERCURY IN REPORTABLE QUANTITIES AS
DEFINED BY OSHA OR EPA.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:23.8 MM HG
Vapor Density:>1
Spec Gravity:1.32
pH:9.0
Viscosity:70-90 KU
Evaporation Rate & Reference:<1 (ETHER=1)
Solubility in Water:COMPLETE
Appearance and Odor:WHITE LIQUID; SLIGHT ODOR
Percent Volatiles by Volume:4.7
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS, HYDROFLUORIC ACID.
Stability Condition to Avoid:ELEVATED TEMPERATURES, CONTACT WITH
OXIDIZING AGENTS.
Hazardous Decomposition Products:CARBON MONOXIDE AND CARBON DIOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. AVOID DISCHARGE TO NATURAL WATERS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:8047853 BLUE
CAGE:DO804
CAGE:DO804
CAGE:38360
============= Composition/Information on Ingredients =============
Ingred Name:DIETHYLENE GLYCOL BUTYL ETHER ACETATE, ETHANOL, 2-
(2-BUTOXYETHOXY), BUTYL CARBITOL ACETATE
CAS:124-17-4
RTECS #:KJ9275000
Fraction by Wt: 10-25%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: MODERATE IRRITATION. SKIN:
SLIGHT IRRITATION. INHALATION: NASAL & RESPIRATORY IRRITATION, CNS
EFFECTS, DEATH. INGESTION: GI IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, DIZZINESS, WEAKNESS, FATIGUE,
NAUSEA, HEADACHE, UNCONSCIOUSNESS, VOMITING, DIARRHEA, REDNESS,
TEARING.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR 15 MINS. SKIN: WASH W/SOAP & WATER.
INHALATION: REMOVE TO FRESH AIR. INGESTION: IF CONSCIOUS GIVE 2
GLASSES OF WATER & INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Flash Point:237F
Extinguishing Media:DRY CHEMICAL, CO2, ALCOHOL FOAM.
Fire Fighting Procedures:WEAR A SELF CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:VAPORS ARE >AIR & MAY TRAVEL ALONG GROUND
TO DISTANT IGNITION SOURCE.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE IGNITION SOURCES. ABSORB MATERIAL
W/VERMICULITE/FLOOR ABSORBENT. DISPOSE OF CONTAMINATED MATERIALS
======================Handling and Storage ======================
Handling and Storage Precautions:FOR FLAMMABLE/COMBUSTIBLE PRODUCTS,
FOLLOW STORAGE & HANDLING GUIDELINES PRESENT IN NFPA 30 FLAMMABLE &
COMBUSTIBLE LIQUIDS CODE.
Other Precautions:CONTAINERS MAY BE HAZARDOUS WHEN EMPTIED, SINCE
EMPTIED CONTAINERS RETAIN PRODUCT RESIDUES WHICH CAN GENERATE
VAPORS W/IN FLAMMABLE LIMITS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:SUFFICIENT TO MAINTAIN OPERATOR EXPOSURE <APPLICABLE
OCCUPATIONAL EXPOSURE STANDARDS.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
USE OF A HAZARDOUS CHEMICAL MAY REQUIRE SUPPLEMENTAL VENTILATION FOR
PROTECTION OF PERSONNEL & FOR CONTROLLING FIRE/EXPLOSION HAZARD. A
QUALIFIED INDEPENDENT TESTING COMPANY CAN DETERMINE IF EXISTING
CONCENTRATIONS ARE W/IN ESTABLISHED RECOMMENDED/PERMISSIBLE
EXPOSURE LEVELS.
================== Physical/Chemical Properties ==================
Vapor Pres:<0.01
Evaporation Rate & Reference:(N-BU AC = 1): <0.01
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLUE LIQUID/SEMI-SOLID INK W/MILD ODOR.
Percent Volatiles by Volume:15
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ALKALIES/MINERAL ACIDS.
Stability Condition to Avoid:HEAT, FLAME & OTHER IGNITION SOURCES.
Hazardous Decomposition Products:CO & CO2.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS. IT'S THE RESPONSIBILITY OF THE GENERATOR OF THE WASTE
TO DETERMINE WHETHER THE WASTE GENERATED MEETS THE FEDERAL/STATE
HAZARDOUS WASTE CRITERIA.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:EA 937.2 PART C
CAGE:HYSOL
CAGE:33564
CAGE:HYSOL
============= Composition/Information on Ingredients =============
Ingred Name:ACETIC ACID (SARA III)
CAS:64-19-7
RTECS #:AF1225000
Fraction by Wt: 100%
OSHA PEL:10 PPM
ACGIH TLV:10 PPM/15 STEL; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Effects of Overexposure:CORROSIVE.CAN CAUSE BURNS,LACRIMATION &
CONJUNCTIVITIS;IRRITATION OF MEMBRANES.
======================= First Aid Measures =======================
First Aid:EYES:IMMEDIATELY FLUSH W/PLENTY OF H*2O FOR @ LEAST 15 MIN.
SKIN: IMMEDIATELY FLUSH WITH PLENTY OF H*2O & REMOVE ALL CLOTHING.
===================== Fire Fighting Measures =====================
Flash Point:109F (42.7C),CC
Lower Limits:5.4
Upper Limits:16.0
Extinguishing Media:DRY CHEM,HALON FIRE EXTINGUISHER,H*2O
SPRAY,FOAM/FOG.
Fire Fighting Procedures:USE SCBA WHEN FIGHT FIRES IN CONFINED AREAS.
Unusual Fire/Explosion Hazard:DENSE SMOKE & TOXIC GASES MAY BE
LIBERATED.
================== Accidental Release Measures ==================
& RESPIRATOR. COVER W/ABSORBENT MATERIAL,THEN SCRAPE UP & TRANSFER
TO METAL CONTAINERS.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP PRODUCT COOL IN ACCORDANCE
W/LABEL INSTRUCTIONS.
Other Precautions:FOLLOW RECOMMENDED ACID USE PROCEDURES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED MASK RECOMMENDED,NOT
NECESSARY IF GOOD VENT.
Ventilation:LOCAL EXHAUST & MECHANICAL VENTILATION RECOMMENDED.
Other Protective Equipment:AS NEEDED TO PROTECT SKIN & CLOTHING.
Supplemental Safety and Health
VAP PRESS:11.4 MM HG. DATE OF PREP:JULY 31,1986.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:245F (118C)
Vapor Density:2.07
Spec Gravity:1.0492
Solubility in Water:YES
Appearance and Odor:CLEAR,COLORLESS WITH PUNGENT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CHROMIC ACID,SODIUM PEROXIDE,ETHYLENEDIAMINE.
Hazardous Decomposition Products:EMITS TOXIC FUMES WHEN HEATED TO
DECOMPOSITION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IAW LOCAL,STATE & FEDERAL
REGULATIONS.DISPOSE OF AS HAZ WASTE ACCORDING TO D.O.T. HAZ
CLASS.IF NOT REGULATED BY D.O.T.,DISPOSE OF AS ORM-E.DISPOSAL
METHOD CAN BE LAND BURIAL/CHEMICAL INCINERAT ION AS REGULATED BY
ALL GOVERNMENT AGENCIES.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MIL-C-46168D PART B 4:1 BLEND
Kit Part:Y
Preparer's Name:MICHAEL J LICHATOWICH
CAGE:02388
CAGE:02388
============= Composition/Information on Ingredients =============
Ingred Name:HOMOPOLYMER OF HDI
CAS:28182-81-2
RTECS #:NQ9170000
Fraction by Wt: 75%
Other REC Limits:NONE SPECIFIED
Ingred Name:HEXAMETHYLENE DIISOCYANATE *(RESIDUAL MONOMER CONTENT
LESS THAN 0.5% BASED ON RESIN SOLIDS AT TIME OF MFR.**
CAS:822-06-0
RTECS #:MO1740000
Fraction by Wt: *
Other REC Limits:NONE SPECIFIED
ACGIH TLV:0.005 PPM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:**AFTER 3-6 MO STORAGE, THE FREE MONOMER CONTENT MAY RISE
(MAX 1.6). MFR ALSO RECOMMENTS A CEILING LEVEL OF 0.02 PPM.
RTECS #:9999999ZZ
Other REC Limits:NONE SPECIFIED
Ingred Name:XYLENE (SARA 313) (VAPOR PRESSURE 7.0 MM HG @ 20C)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 12.5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/150 PPM STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:N-BUTYL ACETATE (VAPOR PRESSURE 10 MM HG @ 20C)
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: 12.5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:150 PPM
ACGIH TLV:150 PPM/200 PPM STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:VOC: 2.21 LB/GL
RTECS #:9999999VO
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL 4,300 MG/KG RAT. INHAL ***
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL: IRRIT, REDUCED LUNG FUNCTION
(BREATHING OBSTRUCTION),LUNG DAMAGE, BRONCHITIS, BRONCHIAL SPASM,
PULMONARY EDEMA. CHEMICAL/HYPERSENSITIVE PNEUMONITIS. EYE, NOSE,
THROAT IRRIT. HIGH CONC CAN CAUSE DEATH. SOME INDIVIDUALS MAY
DEVELOP ISOCYANATE SENSITIZATION (LATER REACT W/EXPOS BELOW TLV).
MORE INFORMATION ON FILE.
Explanation of Carcinogenicity:N/K ***137 TO 1150 MG/M3 RAT. DERMAL
>1,700 MG/KG RABBIT.
Effects of Overexposure:BURNING SENSATION (NOSE, THROAT, LUNGS), RUNNY
NOSE, SORE THROAT, COUGHING, WHEEZING, ASTHMATIC ATTACK, LUNG
SENSITIVITY, CHEST DISCOMFORT, SHORTNESS OF BREATH, FEVER, CHILLS.
DRYNESS (THROAT), TIGHTN ESS (CHEST). HEADACHE, NAUSEA, NARCOSIS,
FATIGUE, LOSS OF APPETITE. REDNESS, RASH, SWELLING, SCALING,
BLISTERING. ****
Medical Cond Aggravated by Exposure:ASTHMA & OTHER RESPIRATORY
DISORDERS (BRONCHITIS, EMPHYSEMA, HYPERREACTIVITY), SKIN ALLERGIES,
ECZEMA. ****LOSS OF
COORDINATION, LOSS OF INTELLECTUAL ABILITY.
======================= First Aid Measures =======================
First Aid:INHAL:MOVE TO FRESH AIR. ADMIN OXYGEN/ARTIF RESP. CALL DR.
ASTHMATIC SYMPTOMS? TREAT SYMPTOMATICALLY. CALL DR. SKIN:REMOV
CONTAM CLOTH. WASH W/SOAP & WTR. SEVERE EXPOS, REMOVE CLOTH, GET
UNDER SAFETY SHOWER. CALL DR. LESSER EXPOS-CALL DR, IF IRRIT
DEVELOPS. EYE:FLUSH W/WTR 15 MIN, LIFT LIDS. REFER TO DR. INGEST:NO
VOMIT. 1-2 CUPS MILK/WATER. NOTHING BY MOUTH UNCONSCIOUS/CONVULSING
PERSON. CALL DR.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:91.0F,32.8C
Lower Limits:1.0
Upper Limits:7.6
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL.
Fire Fighting Procedures:FULL EMERG EQUIP (SCBA & FULL PROTECT CLOTH).
DURING FIRE, HDI & OTHER TOXIC GASSES MAY BE GENERATED. ISOLATE
FROM IGNIT SOURCE. CLSD CNTNR MAY EXPLODE W/HEAT.*
Unusual Fire/Explosion Hazard:*CLSD CNTNR MAY BURST WHEN CONTAM W/WATER
CREATING CO2. SOLVENT VAPOR HEAVIER THAN AIR, MAY TRAVEL ALONG
GROUND TO IGNITION SOURCE & FLASHBACK TO VAPOR SOURCE.
================== Accidental Release Measures ==================
Spill Release Procedures:EVAC PEOPLE. REMOVE IGNIT SOURCES. VENT.
DIKE/STOP SPILL. NOTIFY AUTHORITIES. COVER SPILL W/ABSORB/DECONTAM
SOLUTION ON SPILL, LET REACT 10 MIN. COLLECT PROD IN CNTNR, COVER
LOOSELY, STAND 24 HR. WASHSPILL W/DECOMTAM. RESPIRATOR PROTECT
RECOMMENDED.
Neutralizing Agent:DECONTAM SOLUTIONS: NONIONIC SURFACTANT TERGITOL
TMN-10 (20%) WATER (80%);#
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE: MINIMUM -30F/122F MAX. KEEP
FROM IGNITION SOURCE/HEAT. GRND CNTNRS DURING STORAGE/TRANSFER.
STORE IN CLSD CNTNRS. DO NOT RESEAL IF CONTAM.
Other Precautions:AVOID CONTACT W/SKIN & EYES. USE OF POS PRESSURE AIR
SUPPLIED RESP MAY BE NECESSARY FOR MIXING OR BRUSH APPLICATIONS.
SEE ADDITIONAL INFO ON FILE. FOLLOW LABEL INSTRUCT.
#CONCENTRATED AMM ONIA (3-8%) DETERGENT (2%) WATER (90-95)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESPIRATOR RECOMM/APPROVED IN ISOCYANATE
CONTAINING ENVIRONMENTS MAY BE NECESSARY. USE AIR PURIFYING
RSPRTR/POSITIVE PRESSURE SUPPLIED AIR RSPRTR APPROPRIATE FOR
ISOCYANATE CONCENTRATIONS. SEE ORIGINA L MSDS ON FILE FOR FURTHER
INFORMATION.
Ventilation:EXHAUST VENT SUFF TO KEEP AIRBORNE CONC OF HDI AND
POLYISOCYANATE BELOW TLV. EXHAUST AIR MAY NEED TO BE CLEANED.
Other Protective Equipment:COVER AS MUCH SKIN AS POSSIBLE W/APPROPRIATE
CLOTHES. IF SKIN CREAMS USED, KEEP AREA PROTECTED BY ONLY CREAM TO
MINIMUM.
Work Hygienic Practices:PRECAUTIONS TO AVOID SKIN/EYE CONTACT/BREATHE
VAPOR. WASH CONTAM CLOTHING BEFORE REUSE. EYEWASH & SFTY SHOWERS
NEEDED.
Supplemental Safety and Health
KEY1:F4. KIT CONSISTS OF TWO PARTS. PART ONE HAS PNI A, PART TWO HAS
PNI B, SAME NSN. FOR PREVIOUS FORMULATION, SEE PNI B, SAME NSN.
================== Physical/Chemical Properties ==================
HCC:F2
Vapor Density:> AIR
Viscosity:183 MPAS @20C
Evaporation Rate & Reference:SLOWER ETHER (BU AC=1)
Solubility in Water:INSOL/REACTS W/WATER
Appearance and Odor:CLEAR TO PALE YELLOW LIQUID/SOLVENT ODOR
Percent Volatiles by Volume:CA 30
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER, AMINES, STRONG BASES, ALCOHOLS, METAL COMPOUNDS, AND SURFACE
ACTIVE MATERIALS.
Stability Condition to Avoid:MOISTURE, HIGH TEMPERATURES, SHOCK FROM
DROPPING.
Hazardous Decomposition Products:BY HIGH HEAT AND FIRE: CARBON DIOXIDE,
CARBON MONOXIDE, OXIDES OF NITROGEN, TRACES OF HCN AND HDI.
Conditions to Avoid Polymerization:MAY OCCUR IF IN CONTACT W/MOISTURE
OR OTHER MATERIALS WHICH REACT W/ISOCYANATES. MAY OCCUR AT
TEMPERATURES OVER 400 F.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORD W/ FEDERAL, STATE & LOCAL
ENVIRONMNTL CNTRL REGS. INCINERATION PREFERRED. IGNITABLE HAZARDOUS
WASTE (PROD RESIDUE/FLAMMABLE SOLVENT VAPOR). DECONTAMINATE
CONTAINERS PRIOR TO DISPOSAL . DON'T HEAT/CUT ON OR NEAR EMPTY
CONTAINERS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:3825 UHS SC 32 OUNCE
CAGE:0U826
CAGE:0U826
CAGE:32204
============= Composition/Information on Ingredients =============
Ingred Name:2-AMINOETHANOL, ETHANOLAMINE, MONOETHANOLAMINE
CAS:141-43-5
RTECS #:KJ5775000
Fraction by Wt: 35-40%
Other REC Limits:3 PPM
OSHA PEL:3 PPM
ACGIH TLV:3 PPM
Ingred Name:ACRYLATE POLYMER,POLYACRYLATE,CARBOMER 940,POLYACRYLIC
ACID,ACRYLIC RESIN,ACRYLIC OLIGOMER (EMULSION),ACRYLIC POLYMER
CAS:9003-01-4
RTECS #:AT4680000
Fraction by Wt: 3-8%
Ingred Name:2-BUTOXYETHANOL (ETHYLENE GLYCOL MONOBUTYL ETHER), BUTYL
CELLOSOLVE, BUTYL GLYCOL, GLYCOL ETHER EB
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: 18-23%
Other REC Limits:25 PPM (SKIN)
OSHA PEL:25 PPM (SKIN)
ACGIH TLV:25 PPM (SKIN)
Ingred Name:AMMONIUM HYDROXIDE, AQUA AMMONIA
CAS:1336-21-6
RTECS #:BQ9625000
Fraction by Wt: 5-10%
Other REC Limits:25 PPM
OSHA PEL:25 PPM
ACGIH TLV:25 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 25-35%
Ingred Name:ALKOXYLATED LINEAR ALCOHOL
Fraction by Wt: 3-8%
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RATS): >5000 MG/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: CORROSIVE, PERMANENT DAMAGE.
SKIN: CORROSIVE, CHEMICAL BURNS. INHALATION: IRRITATION OF
RESPIRATORY TRACT. INGESTION: HARMFUL/FATAL, CORROSIVE TO MOUTH &
DIGESTIVE TRACT. CONTAINS GLYCOL ETHER & ALKANOLAMINE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, BURNS.
Medical Cond Aggravated by Exposure:CHRONIC RESPIRATORY DISORDERS,
ASTHMA, CHRONIC BRONCHITIS, EMPHYSEMA, PRE-EXISTING SKIN DISORDERS.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH IMMEDIATELY W/WATER FOR 20 MINS. SKIN: RINSE
W/PLENTY OF WATER. INHALATION: REMOVE TO FRESH AIR. INGESTION:
DRINK 1-2 GLASSES OF WATER/MILK. DON'T INDUCE VOMITING. OBTAIN
MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:FOAM, CO2, WATER FOG.
Fire Fighting Procedures:NORMAL FIRE FIGHTING PROCEDURES MAY BE USED.
COOL & USE CAUTION WHEN APPROACHING/HANDLING FIRE EXPOSED
CONTAINERS.
================== Accidental Release Measures ==================
Spill Release Procedures:LARGE: DIKE & ABSORB W/OIL-DRI/SIMILAR INERT
MATERIAL. SWEEP/SCRAPE UP & CONTAINERIZE. RINSE AFFECTED AREA
THOROUGHLY W/WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY PLACE W/ADEQUATE
VENTILATION. KEEP CONTAINER WELL CLOSED WHEN NOT IN USE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR APPROPRIATE RESPIRATORY PROTECTION IF
MISTS/VAPORS AREN'T ADEQUATELY CONTROLLED BY LOCAL VENTILATION.
Ventilation:GENERAL ROOM VENTILATION ADEQUATE. LOCAL EXHAUST IF
SUBSTANTIAL AMOUNTS OF MISTS/VAPORS PRESENT.
Other Protective Equipment:APPROPRIATE PROTECTIVE EQUIPMENT
Work Hygienic Practices:USE GOOD PERSONAL HYGIENE PRACTICES.
REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Spec Gravity:1.01
pH:>12
Solubility in Water:COMPLETE
Appearance and Odor:BLUE GREEN LIQUID W/FRAGRANT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, MURIATIC ACID.
Hazardous Decomposition Products:NORMAL PRODUCTS OF COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF UNDILUTED PRODUCT AS CORROSIVE WASTE
IAW/FEDERAL, STATE & LOCAL REGULATIONS. CORROSIVE LIQUIDS UN1760
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MIL-L-81352B TY.I #15044 BLUE
Preparer's Name:ERNEST CARTER
CAGE:58963
CAGE:58963
============= Composition/Information on Ingredients =============
Ingred Name:METHYL ETHYL KETONE
CAS:78-93-3
RTECS #:EL6475000
= Wt:7.
OSHA PEL:590 MG/M3;200 PPM
ACGIH TLV:590 MG/M3;200 PPM
ACGIH STEL:885 MG/M3;300 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:METHYL METHACRYLATE RESIN
= Wt:50.
Ingred Name:DIOCTYL PHTHALATE
CAS:117-81-7
RTECS #:TI0350000
= Wt:4.
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3
ACGIH STEL:10 MG/M3
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:ACETONE
CAS:67-64-1
RTECS #:AL3150000
= Wt:10.
OSHA PEL:2400 MG/M3;1000 PPM
ACGIH TLV:1780 MG/M3;750 PPM
ACGIH STEL:2380 MG/M3;1000 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:N-BUTYL ALCOHOL
CAS:71-36-3
RTECS #:EO1400000
= Wt:3.
OSHA PEL:300 MG/M3;100 PPM
ACGIH STEL:C152 MG/M3;C50 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:XYLENE
CAS:1330-20-7
RTECS #:ZE2100000
= Wt:7.
ACGIH TLV:434 MG/M3;100 PPM
ACGIH STEL:651 MG/M3;150 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ETHYLENE GLYCOL MONOBUTYL ETHER
CAS:111-76-2
RTECS #:KJ8575000
= Wt:7.
OSHA PEL:240 MG/M3;50 PPM
ACGIH TLV:121 MG/M3;25 PPM
Ingred Name:METHYL AMYL KETONE
CAS:110-43-0
RTECS #:MJ5075000
= Wt:4.
OSHA PEL:465 MG/M3;100 PPM
ACGIH TLV:233 MG/M3;50 PPM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:DIRECT CONTACT TO EYES MAY CAUSE
IRRITATION. PROLONGED AND/OR REPEATED CONTACT MAY CAUSE SKIN
IRRITATION. INHALATION OF HIOGH CONCENTRATIONS OF VAPORS MAY LEAD
TO LUNG CHANGES, NAUSEA, VOMITING, COUGH , PULMONARY IRRITATION,
AND CENTRAL NERVOUS SYSTEM DEPRESSION, INGESTION MAY CAUSE
GASTROINTESTINAL DISTURBANCES. ASPIRATION OF THIS PRODUCT INTO THE
LUNGS MAY CAUSE PNEUMONITIS. PULMONARY EDEMA AND H EMORRAGE.
Effects of Overexposure:INHALATION: BREATHING OF HIGH VAPOR
CONCENTRATIONS MAY CAUSE DROWSINESS, DIZZINESS, FATIGUE, FOLLOWED
BY COMA. EYE: DIRECT CONTACT AND/OR CONTACT WITH VAPORS MAY CAUSE
IRRITATION. SKIN: PROLONGED AND/ OR REPEATED CONTACT MAY CAUSE
IRRITATION AND/OR DERMATITIS. MAY BE ABSORBED THROUGH THE SKIN.
SKIN ABSORPTION: PROLONGED OR REPEATED EXPOSURE CAN CAUSE MODERATE
IRRITATION, DEFATTING, AND DERMATITIS. INGESTION: ASPIRATION OF
THIS PRODUCT INTO THE LUNGS MAY CAUSE PNEUMONTITIS, PULMONARY EDEMA
AND HEMORRAGE. INGESTION MAY CAUSE GASTROINTESTINAL DISTURBANCES.
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH PRE-EXISTING
DISEASES IN OR HISTORY OF AILMENTS INVOLVING SKIN CENTRAL NERVOUS
SYSTEM, LIVER AND KIDNEY.
======================= First Aid Measures =======================
First Aid:EYE CONTACT: IMMEDIATELY FLUSH WITH LARGE AMOUNTS OF WATER
FOR 15 MINUTES, SEEK MEDICAL AID. SKIN: WASH THOROUGHLY WITH SOAP
AND WATER. SEEK MEDICAL AID. INGESTION: IMMEDIATELY SEEK MEDICAL
AID. DO NO T INDUCE VOMITING. DO NOT ATTEMPT TO GIVE ANYTHING BY
MOUTH TO AN UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:=-20.C, -4.F
Lower Limits:0.3%
Upper Limits:12.8%
Extinguishing Media:FOAM, CO2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:APPROVED GAS MASK REQUIRED FOR FIRE FIGHTING
PERSONEL. WATER MAY BE INEFFECTIVE. WATER MAY BE USED TO COOL
CONTAINERS. IF WATER IS USED, FOG NOZZLES ARE PREFERRED.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE
FROM HEAT, ELECTRICAL EQUIPMENT, SPARKS, AND OPEN FLAME. CLOSED
CONTAINERS MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:STOP LEAK IF NO RISK INVOLVED. REMOVE ALL
SOURCES OF IGNITION. STAY UPWIND. ABSORB WITH INERT MATERIAL. FLUSH
AREA WITH WATER. VENTILATE AREA FOR AT LEAST 24 HOURS OR UNTIL AREA
HAS BEEN DECLARED SAFE .
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS CLOSED AND UPRIGHT TO
PREVENT LEAKAGE. AVOID FLAMES, WELDING, OPEN LIGHTS, ETC. AVOID
BREATHING OF VAPORS AND SPRAY MIST. AVOID SKIN AND EYE CONTACT.
Other Precautions:MAINTAIN GOOD PERSONAL HYGIENE. DO NOT USE IN
CONFINED AREAS, TANK OR PIT, WITHOUT ADEQUATE VENTILATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF VENTILATION DOES NOT MAINTAIN INHALATION
EXPOSURES BELOW TLV (PEL). USE MSHA/NIOSH APPROVED UNITS. USE UNITS
PER CURRENT 29 CFR 1910.134 AND FOLLOW MANUFACTURERES' INSTRUCTIONS
AND WARNINGS. IF WIT HIN OSHA PROTECTION FACTOR, AIR PURIFYING
OV/FILTER UNITS OK FOR USE.
Ventilation:LOCAL AND MERCHANICAL EXHAUST.
Other Protective Equipment:EYE BATH AND SAFETY SHOWER.
Work Hygienic Practices:MAINTAIN GOOD PERSONAL HYGIENE. DO NOT USE IN
CONFINED AREAS WITHOUT ADEQUATE VENTILATION.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:131-724 DEG F
Vapor Density:HEAVIER
Spec Gravity:1.0
VOC Pounds/Gallon:274
VOC Grams/Liter:2.28
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:ESSENTIALLY NIL
Appearance and Odor:VISCOUS LIQUID WITH STRONG SOLVENT ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:FLAMES, SPARKS, SMOKING AND HEAT.
Hazardous Decomposition Products:CARBON MONOXIDE AND CARBON DIOXIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:USE INERT ABSORBENT MATERIALS ON SPILLS. DISPOSE
OF IN ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL REGULATIONS.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ENPLATE CU-406 A, 3317
Preparer's Name:S. D. KOCH
CAGE:02258
CAGE:02258
============= Composition/Information on Ingredients =============
Ingred Name:COPPER (II) SULFATE (1:1); (CUPRIC SULFATE) (SARA III)
CAS:7758-98-7
RTECS #:GL8800000
Fraction by Wt: <10%
Other REC Limits:1MG/M3 DUST/MIST(CU)
OSHA PEL:0.1 MG/M3 FUME (CU)
ACGIH TLV:0.2 MG/M3 FUME (CU)
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:FORMALDEHYDE (SARA III)
CAS:50-00-0
RTECS #:LP8925000
Fraction by Wt: <10%
OSHA PEL:SEE 1910.1048
ACGIH TLV:C 0.3 PPM; A2; 9293
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:METHANOL; (METHYL ALCOHOL)
CAS:67-56-1
RTECS #:PC1400000
Fraction by Wt: <5%
OSHA PEL:S,200PPM/250STEL
ACGIH TLV:S,200PPM/250STEL; 93
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:2-PROPANOL, 1,1',1'',1'''-(ETHYLENEDINITRILO) TETRA-;
(N,N,N',N'-TETRAKIS (2-HYDROXY-PROPYL)ETHYLENEDIAMINE) (QUADROL)
CAS:102-60-3
RTECS #:UB5604000
Fraction by Wt: <15%
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: >70%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: INHAL:HIGHLY IRRITATING TO
NASAL PASSAGES. CAN CAUSE INFLAMM OF LINING OF NOSE, THROAT &
LUNGS. OVEREXPOS MAY CAUSE HDCH, NAUS, DIZZ & BLURRING OF VISION.
INGEST:CAN CAUSE SEV IRRIT & INFLAMM O F MOUTH, THROAT & STOM, AS
WELL AS BLINDNESS, STUPOR, NAUS, VOM & POSS DEATH. SKIN:CAN CAUSE
IRRIT & (EFTS OF OVEREXP)
Explanation of Carcinogenicity:FORMALDEHYDE:GRP 2A IARC,VOL
7,P.211,1987; ANTIC TO BE CARCIN, NTP 6TH ANNUAL RPT ON
CARCINOGENS,1987; OSHA REGULATED.
Effects of Overexposure:HLTH HAZ:DERMATITIS. EYES:VAPOR CAUSES
IRRITATION & TEARING. CONTACT W/LIQUID CAN CAUSE SEVERE BURNS &
POSSIBLE BLINDNESS. CHRONIC: MAY CAUSE SENSITIZATION & REDUCED
VISION. LIFETIME INHALATION STUDY OF RATS EXPOSED TO FORMALDEHYDE
GAS INDICATED DEVELOPMENT OF NASAL CANCERS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE FROM CONTAMD AREA. IF BRTHG HAS STOPPED,
RESUSCITATE & ADMIN OXYGEN IF AVAIL. SEEK IMMED MED ATTN.
INGEST:NEVER GIVE ANYTHING BY MOUTH TO UNCON PERS. OBTAIN IMMED MED
ATTN. IF VOM OCCURS SPONT, KEEP AIRWAY CLEAR. IF SWALLOWED,GIVE
LGE AMTS OF WATER & INDUCE VOM. SEEK IMMED MED ATTN. SKIN:IMMED
WASH W/PLENTY OF WATER FOR 15 MINS. REMOVE CONTAMD CLTHG/FOOTWEAR.
WASH CLTHG (SUP DAT)
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WATER FOG OR SPRAY, CARBON DIOXIDE OR DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:WHEN EXPOSED TO HIGH TEMPERATURES,
PRODUCT MAY RELEASE TOXIC OXIDES OF NITROGEN & SULFUR.
================== Accidental Release Measures ==================
Spill Release Procedures:AVOID CONTACT W/SKIN, EYES & CLOTHING. WEAR
PROT EQUIPMENT. DO NOT BREATHE MIST/VAPORS. CONTAIN SPILL & SOAK UP
IN SUITABLE ABSORBENT. SHOVEL UP INTO PLASTIC LINED STEEL CONTRS &
COVER. FOR MAJOR SPIL LS CONSULT ENTHONE-OMI FOR DISPOSAL
ASSISTANCE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE. KEEP AWAY
FROM ALKALIES & OXIDIZERS. LOOSEN COVER CAUTIOUSLY WHEN OPENING.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPRVD RESP WHEN AIR CONC IS
GREATER THAN TLV/PEL. USE NIOSH/MSHA APPRVD FULL FACE FORMALDEHYDE
OR ACID GAS CARTRIDGE RESP W/IN USE LIMITATIONS OF THESE DEVICES.
IN ALL OTHER SITUATIONS , USE NIOSH/MSHA APPROVED SCBA.
Ventilation:LOCAL EXHAUST RECOMMENDED.
Other Protective Equipment:CHEMICALLY RESISTANT COVERALLS, HAT & SHOES
OR BOOTS. EMERGENCY EYEWASH & SAFETY SHOWER SHOULD BE AVAILABLE.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
FIRST AID PROC:BEFORE REUSE. DISCARD FOOTWEAR IF IT CANNOT BE
DECONTAMD. SEEK IMMED MED ATTN. EYES:IMMED FLUSH W/PLENTY OF WATER
FOR AT LEAST 15 MINS HOLDING LIDS APART TO ENSURE FLUSHING OF
ENTIRE SU RF. WASHING EYES W/IN SEVERAL SECONDS OF EXPOSURE IS
ESSENTIAL TO MINIMIZE DAM. SEEK IMMED MED ATTN.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:210F,99C
Melt/Freeze Pt:M.P/F.P Text:4F,-16C
Spec Gravity:1.093 (H*2O=1)
pH:5.7
Solubility in Water:COMPLETE
Appearance and Odor:BLUE LIQUID; PUNGENT IRRITATING ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALKALIES ALKALI METALS, AMINES, ACIDS & STRONG OXIDIZERS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON MONOXIDE & COPPER COMPOUNDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:FOR WASTE DISPOSAL OF OPERATING SOLUTIONS,
CONSULT ENTHONE-OMI WASTE DISPOSAL PROCEDURES. DISPOSE OF IN
ACCORDANCE W/LOCAL, STATE & FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:1225 GLOSS BLACK RUSTMASTER ENAMEL
CAGE:01PD6
CAGE:01PD6
============= Composition/Information on Ingredients =============
Ingred Name:ETHANOL (ETHYL ALCOHOL), TECSOL, ALCOHOL
CAS:64-17-5
RTECS #:KQ6300000
Fraction by Wt: 1-5%
Other REC Limits:1900 MG/CUM
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM
Ingred Name:XYLENE, DIMETHYLBENZENE, XYLOL (IARC - GROUP 3) *95-2*
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 10-20%
Other REC Limits:100 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM, SKIN
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ETHYL BENZENE *95-2*
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: 1-5%
Other REC Limits:100 PPM
OSHA PEL:435 MG/CUM
ACGIH TLV:434 MG/CUM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ACETONE; DIMETHYL KETONE; 2-PROPANONE
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 40-50%
OSHA PEL:2400 MG/CUM
ACGIH TLV:750 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:2-BUTANONE (METHYL ETHYL KETONE) (MEK)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 1-5%
Other REC Limits:590 MG/CUM
OSHA PEL:200 PPM
ACGIH TLV:590 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ETHYL 3-ETHOXYPROPIONATE, PROPANOIC ACID, 3-ETHOXY-, ETHYL
ESTER
CAS:763-69-9
RTECS #:UF3325000
Fraction by Wt: 5-10%
Ingred Name:TALL OIL FATTY ACIDS, TRIMETHYLOLPROPANE, PENTAERYTHRITOL,
PHTHALIC ANHYDRIDE POLYMER
CAS:67762-04-3
Fraction by Wt: 5-10%
Ingred Name:BENZENE (SUSPECTED HUMAN CARC BY ACGIH, IARC, ANIMAL
CARCINOGEN BY IARC, CARCINOGEN BY NTP - IARC GROUP 1) *95-2*
CAS:71-43-2
RTECS #:CY1400000
Fraction by Wt: 0-0.1%
Other REC Limits:16 MG/CUM
ACGIH TLV:0.3 MG/CUM (A2) IC
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:BUTANE, N-BUTANE
CAS:106-97-8
RTECS #:EJ4200000
Fraction by Wt: 1-5%
Other REC Limits:800 PPM
OSHA PEL:800 PPM
ACGIH TLV:1900 MG/CUM
Ingred Name:ISOBUTANE, 2-METHYLPROPANE
CAS:75-28-5
RTECS #:TZ4300000
Fraction by Wt: 1-5%
Other REC Limits:1000 PPM
OSHA PEL:1800 MG/CUM
ACGIH TLV:1000 PPM
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 10-20%
Other REC Limits:1800 MG/CUM
OSHA PEL:1000 PPM
ACGIH TLV:SIMPLE ASPHYXIANT
Ingred Name:VOLATILE ORGANIC CONTENT: 758.34 GM/L
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHALATION: RESPIRATORY TRACT & MUCOUS
MEMBRANE IRRITANT/CNS DEPRESSION/RESPIRATORY PROBLEMS/ANESTHETIC
EFFECTS/BRONCHITIS/ABNORMAL BLOOD PRESSURE/LIVER-KIDNEY
DAMAGE/PNEUMOCONIOSIS/RESPIRATORY FAILUR E/ASPHYXIATION/DEATH.
SKIN: IRRITANT/DERMATITIS/ABSORPTION. EYES:
IRRITANT/CONJUNCTIVITIS/CORNEAL INJURY/BLINDNESS(SUPP)
Explanation of Carcinogenicity:SEE INGREDIENTS. ACCORDING TO GLIDDEN,
BENZENE IS REGULATED BY OSHA AS A CARCINOGEN.
Effects of Overexposure:IRRITATION/LOSS OF
APPETITE/FATIGUE/DROWSINESS/DIZZINESS/LIGHTHEADEDNESS/HEADACHE/UNCO
ORDINATION/NAUSEA/VOMITING/DIARRHEA/CHEST PAIN/BLURRED
VISION/FLU-LIKE SYMPTOMS/COUGHING/SNEEZING/DIFFICULTY BREAT
HING/FEVER/CHILLS/TREMORS/CONVULSIONS/LOSS OF
CONSCIOUSNESS/ASPHYXIATION/DEFATTING/BLISTERING/TEARING/REDNESS/NAR
COSIS.
Medical Cond Aggravated by Exposure:EYE, SKIN, RESPIRATORY & LUNG
DISORDERS. ASTHMA-LIKE CONDITIONS, KIDNEY/LIVER/NERVOUS SYSTEM
DISORDERS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE & SUPPORT CONTINUED
BREATHING. HAVE TRAINED PERSON GIVE OXYGEN. SKIN: FLUSH W/WATER,
THEN WASH THOROUGHLY W/SOAP & WATER. EYES: FLUSH IMMEDIATELY
W/LARGE AMOUN TS OF WATER FOR 15 MINS. OBTAIN MEDICALATTENTION IN
ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:1F
Extinguishing Media:DRY CHEMICAL/FOAM, WATER FOG, CO2
Fire Fighting Procedures:WATER MAY BE USED TO COOL/PROTECT EXPOSED
CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE/BURST WHEN
EXPOSED TO EXTREME HEAT/FIRE. VAPORS MAY EXPLODE AT AMBIENT
TEMPS/FORM EXPLOSIVE MIXTURES W/AIR AT ELEVATED TEMPS.(SUPP
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE IGNITION SOURCES. VENTILATE
W/EXPLOSION-PROOF EQUIPMENT/EVACUATE AREA. COLLECT W/ABSORBENT, USE
NON-SPARKING TOOLS. PLACE IN PROPER CONTAINER. SHOUT OFF LEAK
SAFELY. DIKE/CONTAIN/PUMP TO STO RAGE/SALVAGE VESSELS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE <80F. KEEP CONTAINERS TIGHTLY
CLOSED/UPRIGHT WHEN NOT IN USE & AWAY FROM IGNITION SOURCES. USE
W/ADEQUATE VENTILATION. DON'T TAKE INTERNALLY.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. AVOID
CONTACT/SKIN/EYES & BREATHING VAPORS. AVOID CONDITIONS WHICH FORMS
INHALABLE PARTICLES. INTENTIONAL MISUSE BY DELIBERATELY
CONCENTRATING & INHALING THE CONTENTS MA Y BE HARMFUL/FATAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHERE REQUIRED, USE ONLY NIOSH/MSHA APPROVED
RESPIRATORS IN ACCORDANCE W/OSHA STANDARD 29 CFR 1910.134.
Ventilation:DILUTION/LOCAL EXHAUST TO PREVENT BUILD-UP OF VAPORS. USE
EXPLOSION PROOF NON-SPARKING EQUIPMENT.
Other Protective Equipment:EYE WASH, SAFETY SHOWER, IMPERVIOUS
CLOTHING, APRON, BOOTS
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. REMOVE/DISPOSE OF CONTAMINATED SHOES. WASH THOROUGHLY AFTER
HANDLING.
Supplemental Safety and Health
HEALTH HAZ CONT'D: INGESTION: LUNG DAMAGE DUE TO ASPIRATION INTO
LUNGS/MOUTH-THROAT-MUCOUS MEMBRANE IRRITANT/CNS
DEPRESSION/ANESTHETIC EFFECT/ABNORMAL BLOOD PRESSURE/LIVER-KIDNEY
DAMAGE/PULMONARY EDEM A/BLINDNESS/PARALYSIS/DEATH. FIRE HAZ CONT'D:
VAPORS >AIR/MAY TRAVEL TO DISTANT IGNITION SOURCE & FLASHBACK.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:11-341F
Appearance and Odor:GLOSS BLACK
Percent Volatiles by Volume:99.65
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS/ACIDS/REDUCING AGENTS/BASES/ALDEHYDES/ALKYL
HALIDES/ISOCYANATES/HALOGENS/AMINES/METALS/SALTS
Stability Condition to Avoid:ELEVATED TEMPS, MOISTURE, HEAT, SPARKS,
OPEN FLAME & OTHER IGNITION SOURCES
Hazardous Decomposition Products:CO/CO2/OXIDES OF NITROGEN/OXIDES OF
SULFUR/OXYGEN/HYDROGEN/CHLORIDE/ALDEHYDES/TOXIC GASES/BARIUM
COMPOUNDS/SMOKE/SOOT.
==================== Disposal Considerations ====================
Waste Disposal Methods:AVOID DISCHARGE TO SEWERS/NATURAL WATERS.
DISPOSE OF IAW/LOCAL, STATE & FEDERAL REGULATIONS. EMPTY CONTAINERS
MAY CONTAIN HAZARDOUS RESIDUES. GROUND EQUIPMENT WHEN TRANSFERRING
TO PREVENT ACCUMULATION OF STATIC CHARGE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:BE SERIES HEAVY DUTY REINHIBITOR 1
Kit Part:Y
Resp. Party Other MSDS Num.:MSDSP145
CAGE:0CXZ7
Contract Num:SP0450-01-M-D177
CAGE:30255
Contract Num:SP0450-99-M-C658
CAGE:30255
CAGE:0CXZ7
============= Composition/Information on Ingredients =============
Ingred Name:ETHYLENE GLYCOL (CONTAINS 0-8%DIETHYLENE GLYCOL)
CAS:107-21-1
RTECS #:KW2975000
Minumum % Wt:30.
Maxumum % Wt:40.
OSHA PEL:50 PPM
ACGIH TLV:50 PPM
ACGIH STEL:C127 MG/M3;C50 PPM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SODIUM MERCAPTOBENZOTHIAZOLE
CAS:2492-26-4
Minumum % Wt:1.
Maxumum % Wt:5.
Ingred Name:POTASSIUM HYDROXIDE (MSDS LISTS CAS# 1310-58-2 WHICH IS
INVALID CAS#)
CAS:1310-58-3
RTECS #:TT2100000
Minumum % Wt:7.
Maxumum % Wt:13.
OSHA PEL:2 MG/M3 CEILING
ACGIH TLV:2 MG/M3 CEILING
ACGIH STEL:C2 MG/M3
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SODIUM SILICATE
CAS:1344-09-8
Minumum % Wt:3.
Maxumum % Wt:6.
Other REC Limits:2 MG/M3 CEILING
Ingred Name:SODIUM TOLYLTRIAZOLE
CAS:64665-57-2
Minumum % Wt:1.
Maxumum % Wt:5.
OSHA PEL:NONE ESTABLISHED
ACGIH TLV:NONE ESTABLISHED
Ingred Name:SODIUM BORATE
CAS:1303-96-4
RTECS #:VZ2275000
Minumum % Wt:7.
Maxumum % Wt:13.
OSHA PEL:10 MG/M3
ACGIH TLV:5 MG/M3
Ingred Name:NON-HAZARDOUS INGREDIENTS
> Wt:1.
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Minumum % Wt:20.
Maxumum % Wt:50.
===================== Hazards Identification =====================
LD50 LC50 Mixture:NO DATA PROVIDED BY MANUFACTURER
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INGESTION MAY RESULT IN IMMEDIATE &
SEVERE BURNS TO THE LIPS, TONGUE, ORAL MUCOSA & ESOPHAGUS WITH
POSSIBLE GASTROINTESTINAL HEMORRHAGE & PERFORATION, CARDIAC FAILURE
& PULMONARY EDEMA MAY DEVELOP. SE VERE KIDNEY DAMAGE FOLLOWS
SWALLOWING LARGE VOLUMES OF ETHYLENE GLYCOL. MAY BE FATAL. LIVER
INJURY MAY OCCUR. A DELAYED RED SKIN RASH MAY DEVELOP. INHALATION:
EXTREME LUNG IRRITATION WITH POSSIBLE DAM AGE OR DESTRUCTION OF
LUNG TISSUE. SKIN: MAY CAUSE SEVERE SKIN IRRITATION &/OR CHEMICAL
BURNS. EYES: MAY CAUSE RAPID, SEVERE IRRITATION AND/OR BURNS.
CHRONIC: INHALATION MAY PRODUCE SIGNS OF CNS INVOL VEMENT, SKIN
SENSITIZATION & DERMATITIS
Explanation of Carcinogenicity:NONE OF THE INGREDIENTS IS LISTED AS A
CARCINOGEN OR POTENTIAL CARCINOGEN BY IARC, NTP OR OSHA.
Effects of Overexposure:INGESTION: SYMPTOMS OF DROOLING, DIFFICULTY
WITH SWALLOWING, BREATHING & SPEAKING AND CHEST PAIN MAY BE NOTED.
MAY CAUSE ABDOMINAL DISCOMFORT OR PAIN, NAUSEA, VOMITING,
DIZZINESS, MALAISE, BLURRING OF VISION, IRRITABILITY, LUMBAR PAIN,
OLIGURIA, UREMIA, AND CENTRAL NERVOUS SYSTEM EFFECTS, INCLUDING
IRREGULAR EYE MOVEMENTS, CONVULSIONS & COMA. A DELAYED RED SKIN
RASH MAY DEVELOP. INHALATION: DIFFIC ULT BREATHING, RESPIRATORY
DISTRESS, NAUSEA, HEADACHE, VOMITING, IRREGULAR EYE MOVEMENTS.
SKIN: SEVERE IRRITATION, BURNS. EYES: SEVERE IRRITATION, BURNS,
BLINDNESS.
Medical Cond Aggravated by Exposure:MAY AGGRAVATE EXISTING KIDNEY
DISEASE.
======================= First Aid Measures =======================
First Aid:SWALLOWING: DO NOT INDUCE VOMITING. RINSE MOUTH & DRINK A
GLASSFUL OF MILK OR WATER.NOTHING BY MOUTH TO AN UNCONSCIOUS
PERSON. GET IMMEDIATE MEDICAL ATTENTION BY CALLING PHYSICIAN,
POISON CONTROL CE NTER OR HOSPITAL EMERGENCY ROOM. SKIN: REMOVE
CONTAMINATED CLOTHING & SHOES. FLUSH WITH LOTS AMOUNTS OF WATER FOR
AT LEAST 15 MINUTES. IF IRRITATION, OR PAIN DEVELOPS, SEEK MEDICAL
ATTENTION. INHALATI ON: REMOVE TO FRESH AIR. IF BREATHING BECOMES
DIFFICULT, GIVE OXYGEN. GIVE ARTIFICIAL RESPIRATION IF BREATHING
STOPPED. SEEK IMMEDIATE MEDICAL ATTENTION. EYES: FLUSH WITH LOTS OF
WATER FOR AT LEAST 30 MINUTES. SEEK MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:TOC
Flash Point:NO FLASH TO BOIL
Autoignition Temp:Autoignition Temp Text:NOT DE
Lower Limits:NOT DETERMIN
Upper Limits:NOT DETERMIN
Extinguishing Media:WATER FOG, FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:USE POSITIVE PRESSURE SELF-CONTAINED BREATHING
APPARATUS WHEN ENTERING A CONFINED SPACE.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT
FOR HANDLING CORROSIVE MATERIALS. COLLECT FOR DISPOSAL USING AN
ABSORBENT MATERIAL, IE. VERMICULITE, AND PLACE IN A CONTAINER
SUITABLE FOR CORROSIVE WAST E.
Neutralizing Agent:NO DATA PROVIDED BY MANUFACTURER
======================Handling and Storage ======================
Handling and Storage Precautions:CORROSIVE! PREVENT CONTACT WITH EYES,
SKIN & CLOTHING. IMMEDIATELY REMOVE CONTAMINATED CLOTHING & LAUNDER
BEFORE REUSE. WEAR PROPER PROTECTIVE CLOTHING WHEN HANDLING. DO NOT
BREATHE VAPORS OR MISTS T HAT MAY GENERATE IN USING THE CHEMICALS.
USE ONLY WITH PROPER VENTILATION. (SEE OTHER INFORMATION)
Other Precautions:FOLLOW ALL RECOMMENDED PRECAUTIONS IN HANDLING EMPTY
CONTAINERS. DO NOT CUT OR WELD ON OR NEAR CONTAINER, EVEN EMPTY. DO
NOT REUSE EMPTY CONTAINERS. EMPTY CONTAINERS CONTAIN PRODUCT
RESIDUES & MAY BE DANGEROUS. OBSERVE ALL REQUIREMENTS OF PLANT,
COMPANY OR GOVERNMENT REGULATIONS. KEEP OUT OF REACH O F CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NEEDED UNDER NORMAL USE CONDITIONS. FOR
OPERATIONS WHERE THE TLV MAY BE EXCEEDED, A NIOSH/MSHA APPROVED
RESPIRATOR WITH AN ORGANIC VAPOR CARTRIDGE & A DUST/MIST PRE-FILTER
OR A SUPPLIED AIR RESPI RATOR IS RECOMMENDED. EQUIPMENT SELECTION
DEPENDS ON CONTAMINANT TYPE & CONCENTRATION, SELECT I/A/W 29 CFR
1910.134 & GOOD INDUSTRIAL HYGIENE PRACTICE. FOR FIRE
Ventilation:GENERAL VENTILATION SHOULD BE ADEQUATE FOR NORMAL USE. FOR
OPERATIONS WHERE THE MATERIAL IS HEATED OR MISTED AND THE TLV MAY
BE EXCEEDED, FORCED VENTILATION
Other Protective Equipment:PROTECTIVE CLOTHING SUCH AS APRON, COVERALL,
AND BOOTS IF NEEDED TO PREVENT SKIN CONTACT. SUITABLE WASHING AND
EYE FLUSHING FACILITIES SHOULD BE AVAILABLE IN THE IMMEDIATE WORK
AREA.
Work Hygienic Practices:CONTAMINATED CLOTHING SHOULD BE IMMEDIATELY
REMOVED AND LAUNDERED BEFORE REUSE.
Supplemental Safety and Health
NOTE TO PHYSICIAN: IN CASE OF INGESTION, THE INDUCTION OF EMESIS SHOULD
BE AVOIDED AS FURTHER CAUSTIC INJURY TO THE ESOPHAGUS MAY OCCUR.
THE BENEFIT OF POSSIBLE REMOVAL OF SOME OF THE INGESTED MATERIA L
BY CAUTIOUS GASTRIC LAVAGE MUST BE WEIGHED AGAINST POTENTIAL
COMPLICATIONS OF THE PROCEDURE SUCH AS SERIOUS BLEEDING
================== Physical/Chemical Properties ==================
HCC:B1
Boiling Pt:>104.4C, 220.F
Melt/Freeze Pt:<-15.C, 5.F
Vapor Pres:NOT DETERMINED
Spec Gravity:1.13-1.29
pH:14.0
Viscosity:NOT DETERMINED
Evaporation Rate & Reference:NOT DETERMINED
Solubility in Water:100
Appearance and Odor:ORANGE-YELLOW
Percent Volatiles by Volume:NOT DETERMIN
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NORMALLY UNREACTIVE; HOWEVER, AVOID STRONG ACIDS, STRONG BASES, STRONG
OXIDIZING AGENTS, AND MATERIALS REACTIVE WITH HYDROXYL COMPOUNDS.
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:BURNING MAY PRODUCE CARBON MONOXIDE
AND/OR CARBON DIOXIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
=================== Toxicological Information===================
Toxicological Information:SIGNIFIGANT LABORATORY DATA WITH POSSIBLE
RELEVANCE TO HUMAN HEALTH HAZARDS: ETHYLENE GLYCOL HAS BEEN SHOWN
TO PRODUCE DOSE-RELATED TERATOGENIC EFFECTS IN RATS & MICE WHEN
GIVEN BY GAVAGE OR DRINKING WATER AT HIGH DOSES/CONCENTRATIONS.
THE MAJOR ROUTE FOR PRODUCING DEVELOPMENTAL TOXICITY IS PERORALLY.
THE ABSENCE OF CARCINOGENIC POTENTIAL FOR ETHYLENE GLYCOL HAS BEEN
SUPPORTED BY NUMEROUS IN-VITR O GENOTOXICITY STUDIES SHOWING THAT
IT DOES NOT PRODUCE MUTAGENIC OR CLASTOGENIC EFFECTS. TOLYLTRIAZOLE
HAS DEMONSTRATED MUTAGENIC ACTIVITY IN A BACTERIAL TEST SYSTEM.
===================== Ecological Information =====================
Ecological:NO DATA PROVIDED BY MANUFACTURER
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE MATERIAL IS A RCRA HAZARDOUS WASTE DUE TO
CORROSIVITY. DISPOSE IN ACCORDANCE WITH FEDERAL, STATE, AND LOCAL
REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:HAZARDOUS MATERIAL DESCRIPTION AND PROPER
SHIPPING NAME: POTASIUM HYDROXIDE, SOLUTION. TECHNICAL NAME: NONE.
HAZARD CLASS: 8. IDENTIFICATION NUMBER: UN1814, PACKING GROUP: II.
LABEL(S) REQUIRED: CORRO SIVE. PLACARD REQUIRED: CORROSIVE.
===================== Regulatory Information =====================
SARA Title III Information:THE PRODUCT CONTAINS THE FOLLOWNG CHEMICALS
SUBJETC TO SARA TITLE III, SECTION 313 REPORTING: ETHYLENE GLYCOL,
CAS# 107-21-1, 30-40%.
Federal Regulatory Information:NO DATA PROVIDED BY MANUFACTURER
State Regulatory Information:CALIFORNIA PROPOSITION 65: THIS PRODUCT
CONTAINS TRACE LEVELS OF CHEMICALS WHICH THE STATE OF CALIFORNIA
HAS FOUND TO CAUSE CANCER AND/OR BIRTH DEFECTS OR OTHER
REPRODUCTIVE HARM.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:1686, ZEP-FLO DRAIN SOLVENT
CAGE:72674
CAGE:27674
CAGE:72674
============= Composition/Information on Ingredients =============
Ingred Name:SULFURIC ACID
CAS:7664-93-9
RTECS #:WS5600000
Fraction by Wt: >90%
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3;3 MG/M3 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: CORR TO SKIN & EYES ON CONT.
EYE CONT CAN PRDCE CORNEAL DAM/BLNDNESS. SKIN CONT CAN PRDCE
INFLAMMATION, REDDENING, & BLISTERING. INHAL OF SPRAY MIST/VAPS MAY
PRDCE IRRIT, BURN, OR DESTRUCTION O F TISSUES IN RESP TRACT,
CHARACT BY COUGH, CHOKING, PAIN/SHORT OF BRTH. SEV OVEREXP MAY LEAD
TO FATAL (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:LUNG DAM. INGEST CAN CAUSE ABDOM PAIN,
NAUS, VOMIT, & COLLAPSE, ALONG W/TISSUE DESTRUCTION IN GI TRACT.
CHRONIC: RPTD/PRLNG CONT W/SPRAY MIST MAY PRDCE CHRONIC EYE IRRIT &
SEV SKIN IRRIT. RPT D/PRLNG EXPOS TO SPRAY MIST MAY PRODUCERESP
TRACT IRRIT LEADING TO FREQUENT ATTACKS OF BRONCHIAL INFECTION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:SKIN: IMMED FLUSH CONTAMD SKIN W/PLENTY OF WATER FOR @ LST 15
MIN. GET MED ATTN IMMED. EYES: IMMED FLUSH W/PLENTY OF WATER FOR @
LST 15 MIN, OCCAS LIFT LIDS. GET MED ATTN @ ONCE. INHAL: MOVE TO
FRESH AIR @ ONCE. IF BRTHG HAS STOPPED, PERFORM ARTF RESP. GET MED
ATTN IMMED. INGEST: DO NOT INDUCE VOMIT. IF CONSCIOUS, GIVE PLENTY
OF WATER TO DRINK. GET MEDICAL ATTENTION @ ONCE.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:NONE
Extinguishing Media:NON-COMBUSTIBLE. MEDIA SUITABLE FOR SURROUNDING
FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:REACTS VIOLENTLY WITH ORGANICS AND
ALUMINUM.
================== Accidental Release Measures ==================
Spill Release Procedures:OBSERVE SFTY PREC DURING CLEAN-UP. ABSORB
SPILL ON AN INERT ABSORB MATL (EG ZEP-O-ZORB); PICK UP & PLACE IN A
CLEAN D.O.T. SPECIFICATION CONTAINER FOR DISPOSAL. WASH AREA
THOROUGHLY WITH A DETERGENT S OLUTION AND THEN RINSE WELL WITH
WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE TIGHTLY CLSD CONTR IN A DRY AREA
@ TEMPS, BETWEEN 40-120F. STORE AWAY FROM HIGHLY ALKALINE PROD &
OXIDIZING CMPDS. KEEP PROD FROM SKIN/EYES.
Other Precautions:DO NOT BREATHE SPRAY MISTS/VAPORS. KEEP AWAY FROM
FOOD AND FOOD PRODUCTS. CLOTHING OR SHOES WHICH BECOME CONTAMINATED
WITH SUBSTANCE SHOULD BE REMOVED PROMPTLY AND NOT REWORN UNTIL
THOROUGHLY CLEANED. KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF VENT IS INADEQUATE, WEAR A NIOSH/MSHA
APPROVED PROPERLY FITTING RESPIRATOR.
Ventilation:IF VAPORS ARE DECTED, VENTILATE WORK AREA BY OPENING
WINDONWS & USING EXHAUST FANS.
Other Protective Equipment:A RUBBER APRON & BOOTS ARE STRONGLY
RECOMMENDED. EMERGENCY EYEWASH & DELUGE SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
WASTE DISP METH: DISPOSED OF IN A CHEMICAL OR INDUSTRIAL WASTE
LANDFILL. IF COMPANY EFFLUENT IS ULTIMATELY TREATED BY A PUBLICLY
OWNED TRTMT WORKS, NEUTRALIZATION OF SPENT TANK-SOLUTIONS
W/SUBSEQUENT DISCHARGE TO SEWER MAY BE POSSIBLE. CONSULT LOCAL,
STATE & FEDERAL AGENCIES FOR PROPER DISPOSAL METHOD IN YOUR AREA.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>550F,>288C
Vapor Pres:1.@300F
Vapor Density:NONE
Spec Gravity:1.83
pH:<1
Evaporation Rate & Reference:SLOW
Solubility in Water:COMPLETE
Appearance and Odor:A COLORLESS, OILY LIQUID WITH LITTLE OR NO ODOR.
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ALKALIS, OXIDIZERS, AND ACTIVE METALS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:HYDROGEN GAS FROM REACTION WITH
STEEL/ACTIVE METALS; SO*2 & SULFUR TRIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:LIQ CANNOT BE SENT TO LANDFILLS UNLESS
SOLIDIFIED. UNUSABLE PROD & SOME COLLECTED, SPENT USE-DILUTIONS MAY
REQ DISP AS HAZ WASTE @ PERMITTED TRTMT/STOR/DISP FACILITY. IN MOST
STATES HAZ WASTE IN TOTAL AMTS OF 220 LBS/LESS PER MONTH MAY BE
(SUPP DATA)
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:25 SEPIA PHOTO OIL COLOR
CAGE:JOHNM
CAGE:JOHNM
============= Composition/Information on Ingredients =============
Ingred Name:HYDRATED ALUMINA, ALUMINUM HYDROXIDE, ALUMINUM OXIDE
HYDRATEALUMINA TRIHYDRATE, ALUMINUM TRIHYDROXIDE
CAS:21645-51-2
RTECS #:BD0940000
Fraction by Wt: 14.2%
OSHA PEL:15 MG/CUM (DUST)
ACGIH TLV:2 MG/CUM (DUST)
Ingred Name:ETHANOL (ETHYL ALCOHOL), TECSOL, ALCOHOL
CAS:64-17-5
RTECS #:KQ6300000
Fraction by Wt: >0.5%
Other REC Limits:1900 MG/CUM
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: CONTACT MAY CAUSE REDNESS,
TEARING. SENSITIVE INDIVIDUALS MAY EXPERIENCE DERMATITIS AFTER LONG
EXPOSURE TO SKIN. INGESTION OF LARGE AMOUNTS MAY CAUSE GI UPSET.
INHALATION: MILD IRRITATION OF NOS E, THROAT.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:REDNESS, TEARING, IRRITATION
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/LUKEWARM WATER FOR 15 MINUTES. SKIN:REMOVE
W/WATERLESS CLEANER THEN WASH W/SOAP & WARM WATER. INHALATION:
REMOVE TO FRESH AIR. INGESTION: KEEP WARM/QUIET. OBTAIN MEDICAL
ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:148F
Extinguishing Media:FOAM, CO2, DRY CHEMICAL
Fire Fighting Procedures:AVOID USE OF WATER, BUT IF ONLY ALTERNATIVE,
IMPLEMENT. USE WATER TO KEEP FIRE EXPOSED CONTAINERS COOL.
Unusual Fire/Explosion Hazard:RAGS & WASTE PAPER CONTAINING THIS
MATERIAL MAY HEAT & BURN SPONTANEOUSLY.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL: PICK UP W/ABSORBENT MATERIAL & TRANSFER
INTO CLOSED METAL CONTAINERS & SOAKED W/WATER. LARGE: CAN BE
SCOOPED UP & PUT INTO CONTAINERS & SALVAGED.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID ACCUMULATION OF CONTAMINATED
RAGS/WIPING MATERIALS BY IMMEDIATE IMMERSION IN WATER, STORE IN
METAL CAN W/TIGHT LIDS.
Other Precautions:PREVENT REPEATED/PROLONGED SKIN CONTACT.
============= Exposure Controls/Personal Protection =============
Ventilation:INTERMITTENT CLEAN AIR EXCHANGES
Other Protective Equipment:EYE WASHES
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Vapor Density:>1
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:0.5
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS, CHLORIDE, CHLORINATED RUBBER
Hazardous Decomposition Products:CO2, CO
==================== Disposal Considerations ====================
Waste Disposal Methods:CAREFULLY INCINERATE/USE SECURE LANDFILL/SPECIAL
WASTE LANDFILL IN ACCORDANCE W/FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:03015103, 1.6 LITERS, NQ2-R PART B COLOR FILM(SUPDAT)
Kit Part:Y
CAGE:0B124
CAGE:0B124
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: >57%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:FERRIC AMMONIUM ETHYLENEDIAMINETETRAACETIC ACID; (FERRIC
AMMONIUM EDTA)
CAS:21285-50-9
Fraction by Wt: <25%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:AMMONIUM BROMIDE
CAS:12124-97-9
RTECS #:BO9170000
Fraction by Wt: <15%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:VENT:BE MAINTAINED. FRESH OUTDOOR AIR SHOULD BE SUPPLIED AT
MIN RATE OF 20 CFM/PERS. VENT EFTIVENESS SHOULD BE (ING 5)
RTECS #:9999999ZZ
Ingred Name:ING 4:SUFFICIENT TO PRDCE GOOD MIXING THROUGHOUT OCCUPIED
SPACE. LOC EXHST:NOT GENERALLY REQD. MECHANICAL:GENERAL(ING 6)
RTECS #:9999999ZZ
RTECS #:9999999ZZ
Ingred Name:OTHER PROT EQUIP:133 FOR GENERAL REQUIREMENTS FOR PERSONAL
PROTECTIVE EQUIPMENT & EYE & FACE PROTECTION.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(ORAL,RAT) >5,000 MG/KG.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:SKIN EYE & MUCOUS MEMBRANE
IRRITATION; DROWSINESS, IRRITABILITY, ATAXIA, VERTIGO; SKIN RASHES.
CHRONIC:DERMATITIS; LARGE DOSES OF INGREDIENTS IN THIS PRODUCT ARE
KNOWN IN LITERATURE TO CAUSE NEU ROLOGICAL SIGNS; SENSORY
DISTURBANCES; INCREASE IN SPINAL FLUID PRESSURE; MANIA;
HALLUCINATIONS; COMA.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NO SPECIFIC CONDITION SPECIFIED.
======================= First Aid Measures =======================
First Aid:EYES:IMMED FLUSH W/WATER FOR MIN OF 15 MINS & SEEK MED ATTN.
SKIN:IMMED WASH W/SOAP & WATER & SEEK MED ATTN IF BURNED/IRRITATED.
INHAL:IMMED REMOVE VICTIM TO FRESH AIR, IF VICTIM IS NOT BRTHG
INITIATE CPR. SEEK MED ATTN. INGEST:IMMED SEEK MED ATTN. CALL LOC
POIS CTL CTR. DO NOT INDUCE VOMIT/DILUTE INGESTED LIQ BY DRINKING
LG QTYS OF WATER W/OUT EMER MED INSTRUCTIONS. CONSULT 29 CFR (SUPP
DATA)
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:CHOOSE MEDIA SUITABLE FOR SURROUNDING MATERIALS.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . WATER SPRAY SHOULD BE USED TO COOL CONTAINERS EXPOSED
TO FIRE & TO DISPERSE VAPORS.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PERSONAL PROTECTIVE EQUIPMENT, DIKE SPILL
& ABSORB LIQUID W/DRY ABSORBENT. PREVENT ANY LIQUID FROM ENTERING
SEWERS OR WATERWAYS. CLEAN UP ABSORBED MATERIAL & PLACE IN SUITABLE
DOT APPROVED CONTAI NER FOR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTACT W/SKIN & EYES. HARMFUL
IF SWALLOWED. AVOID BREATHING MISTS. STORE IN A COOL, DRY, WELL
VENTILATED SPACE.
Other Precautions:DO NOT STORE NEAR STRONG ACIDS. STORE AWAY FROM
INCOMPATIBLE SUBSTANCES LISTED IN INCOMPATIBILITY SECTION. WEAR
PERSONAL PROTECTIVE EQUIPMENT TO PREVENT SKIN &/OR EYE CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESP APPROP FOR EXPOS OF
CONCERN . RESP PROT IS NOT GENERALLY REQD UNDER NORM USE CNDTNS. IF
RESP PROT IS NEC, REFER TO MFR'S RESP SELECTION CRITERIA, DOCUMENT
FOR RESP USE G UIDANCE. ALSO, REFER TO 29 CFR (SUPDAT)
Ventilation:GEN EXHST VENT SATISFYING REQUIREMENTS OF ASHRAE STD
62-1989, "VENT REQUIREMENTS FOR INDOOR AIR QUALITY" SHOULD (ING 4)
Other Protective Equipment:DELUGE SHOWER WHICH MEETS ANSI DESIGN
CRITERIA . EYE WASH. PROT APRON/LAB COAT. CONSULT 29 CFR 1910.132 &
(ING 8)
Work Hygienic Practices:WASH THORO BEFORE EATING, DRINKING,
SMOKING/LEAVING WORKPLACE. CONSULT 29 CFR 1910.141 FOR GEN
REQUIREMENTS FOR SANIT.
Supplemental Safety and Health
MFR'S TRADE NAME/PART NO:BLEACH REPLENISHER. MATLS TO AVOID:BLEACHES
(SODIUM HYPOCHLORITE). MIXING OF THESE CHEMS CAN RSLT IN RELS OF
HAZ/TOX GASES. INHAL OF THESE GASES MAY CAUSE SEV RESP IRRIT. FIRS
T AID PROC:1910.151 REQUIREMENTS FOR MED SERVICES & FIRST AID. RESP
PROT:1910.134 FOR OSHA COMPLIANCE PURPOSES.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:15
Spec Gravity:1.237
pH:6.1
Evaporation Rate & Reference:1 (WATER=1)
Solubility in Water:COMPLETELY SOLUBLE
Appearance and Odor:CLEAR, REDDISH BROWN AQUEOUS SOLUTION W/AMMONIA
ODOR.
Percent Volatiles by Volume:60
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ALKALI; THIS PROD CONTAINS AMMONIA CMPD. DO NOT ALLOW THIS SOLN
TO COME IN CONT W/ HOUSEHOLD/INDUSTRIAL (SUPDAT)
Stability Condition to Avoid:EXCESSIVE HEAT.
Hazardous Decomposition Products:AMMONIA; HYDROGEN BROMIDE; BROMINE,
NITROGEN OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE OF THIS WASTE TO A SANITARY SEWER MAY
REQUIRE APPROVAL OF LOCAL PERMITTING AUTHORITY. OBSERVE ALL
FEDERAL, STATE & LOCAL REGULATIONS WHEN DISPOSING OF ANY CHEMICAL
SUBSTANCE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:355000-03200, MENTOR 28
CAGE:DO849
CAGE:29700
CAGE:DO849
============= Composition/Information on Ingredients =============
Ingred Name:ING 9:IS DFCLT TO REMOVE. "EMPTY" DRUMS SHLD BE COMPLETELY
DRAINED, PROPERLY BUNGED PROMPTLY RETURNED TO DRUM (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10:RECNDTNER. ALL OTHER CNTNRS SHLD BE DISP OF IN
ENVIRON SAFE MANNER & I/A/W GOVT REGS. FOR WORK ON TANKS (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11:REFER TO OSHA REGS, ANSI Z49.1 & OTHER GOVT & INDUS
REFERENCES PERTAINING TO CLEANING, REPAIRING, (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12:WELDING/OTHER CONTEMPLATED OPERATIONS.
RTECS #:9999999ZZ
Ingred Name:VENT:BUILDUP OF EXPLO CONCS OF VAP IN AIR. NO SMOKING,
FLAME OR OTHER IGNITION SOURCES.
RTECS #:9999999ZZ
Ingred Name:HYGIENE PRACT:IF OIL-SOAKED. CLEANSE SKIN THORO AFTER CONT,
BEFORE BREAKS & MEALS & @ END OF WORK PERIOD. PROD (ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15:IS READILY REMOVED FROM SKIN BY WATERLESS HAND
CLEANERS FOLLOWED BY WASHING THORO W/SOAP & WATER.
RTECS #:9999999ZZ
Ingred Name:MINERAL SEAL OIL; (CHEMICALLY NEUTRALIZED MIDDLE
DISTILLATE, PETROLEUM) (PEL/TLV AS OIL MIST)
CAS:64742-30-9
Fraction by Wt: 100%
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3;10 STEL
Ingred Name:SUPDAT:SPILLS AWAY FROM EXPOS. MIN BRTHG OF GASES, VAP,
FUMES/DECOMP PRODUCTS.
RTECS #:9999999ZZ
Ingred Name:EFTS OF OVEREXP:ANIMALS. THERE MAY BE POTNTL RISK OF SKIN
CANCER TO HUMANS FROM PRLNG/RPTD SKIN CONT W/PROD IN (ING 4)
RTECS #:9999999ZZ
Ingred Name:ING 3:ABSENCE OF GOOD PERSONAL HYGIENE. LTD STUDIES ON OILS
THAT ARE VERY ACTIVE CARCINS HAVE SHOWN THAT WASHING (ING 5)
RTECS #:9999999ZZ
Ingred Name:ING 4:ANIMAL'S SKIN W/SOAP & H*2O BTWN APPLICATNS GREATLY
REDUCES TUMOR FORM. PROD HAS LOW ORDER OF ACUTE ORAL & (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5:DERMAL TOX, BUT MIN AMTS ASPIR INTO LUNGS DURING
INGEST/VOMIT MAY CAUSE MILD TO SEV PULM INJURY & POSS DEATH.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC:INGEST:DO NOT INDUCE VOMITING. CALL MD
IMMEDIATELY.
RTECS #:9999999ZZ
Ingred Name:SPILL PROC:WATERCOURSES/EXTENSIVE LAND AREAS. ASSURE
CONFORMITY W/APPLIC GOVERNMENTAL REGULATIONS.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC:OTHER SOURCES OF IGNIT; THEY MAY EXPLODE & CAUSE
INJURY/DEATH. DO NOT ATTEMPT TO CLEAN SINCE RESIDUE (ING 10)
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(ORAL,RAT)>5 G/KG.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:HLTH STUDIES HAVE SHOWN THAT MANY
PETRO HYDROCARBONS & SYNTHETIC LUBRICANTS POSE POTNTL HUMAN HLTH
RISKS WHICH MAY VARY FROM PERS TO PERS. AS PREC, EXPOS TO LIQS,
VAPS, MISTS/FUMES SHLD BE MIN. PRLNG/ RPTD SKIN CONT MAY CAUSE
IRRIT & TENDS TO REMOVE SKIN OILS, POSS LEADING TO IRRIT & DERM.
PROD CNTCTING(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:EYES MAY CAUSE IRRIT. RSLTS FROM
LIFETIME MOUSE SKIN PAINTING STUDY W/PROD SHOW 9 MICE OUT OF 50 DEV
SKIN TUMORS. SUBSTANCE WAS PAINTED ON SHAVED BACKS OF MICE 3
TIME/WK FOR LIFETIME OF ANIMA LS W/NO WASHING BTWN APPLICATNS. ALL
TUMORS NOTED APPEARED DURING LATTER PORTION OF TYPICAL 2-YR
LIFESPAN OF (ING 3)
Medical Cond Aggravated by Exposure:NONE RECOGNIZED.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH W/CLEAR H2O FOR AT LST 15 MINS/ UNTIL IRRIT
SUBSIDES. IF IRRIT PERSISTS, CALL MD. SKIN:REMOVE ANY CONTAM CLTHG
& WASH THORO W/SOAP & H2O. INHAL:IF OVERCOME BY VAP FROM HOT PROD,
IMMED REMOVE FROM EXPOS & CALL MD. IF BRTHG IS IRREG/HAS STOPPED,
START RESUSCITATION; ADMIN O2, IF AVAIL. IF OVEREXPOS TO OIL MIST,
REMOVE FROM FURTHUR EXPOS UNTIL EXCESS OIL MIST CNDTN SUBSIDES.
(ING 7)
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:230F,110C
Lower Limits:0.9%
Upper Limits:7%
Extinguishing Media:FOAM, H2O SPRAY (FOG), DRY CHEM, CO2 & VAPORIZING
LIQ TYPE EXTING AGENTS MAY ALL BE SUITABLE FOR EXTING FIRES
(SUPDAT)
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. USE H2O TO KEEP FIRE-EXPOS CNTNRS COOL. IF LEAK/SPILL HAS NOT
IGNITED, USE H2O SPRAY TO DISPERSE(SUPDAT)
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:RECOVER FREE PROD. ADD SAND, EARTH/OTHER
SUITABLE ABSORB TO SPILL AREA. MIN BRTHG VAPS & SKIN CONT. OPEN ALL
WINDOWS & DOORS. KEEP PROD OUT OF SEWERS & WATERCOURSES BY
DIKING/IMPOUNDING. ADVISE AUTHS IF PROD HAS ENTERED/MAY ENTER
SEWERS, (ING 8)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CNTNRS CLSD WHEN NOT IN USE. DO
NOT STORE NEAR HEAT, FLAME/STRONG OXIDANTS. IN ORDER TO PVNT
FIRE/EXPLO HAZ, USE APPROP EQUIP.
Other Precautions:MIN BRTHG VAP/MIST/FUMES. AVOID PRLNG/RPTD CONT
W/SKIN. "EMPTY" CNTNRS RETAIN RESIDUE (LIQ &/OR VAP) & CAN BE
DANGEROUS. DO NOT PRESSURIZE, CUT, WELD, BRAZE, SOLDER, DRILL,
GRIND/EXPOSE SUCH CNTNRS TO HEAT, FLAME, SPKS, STATIC ELEC/ (ING
9)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED SUPPLIED-AIR RESPIRATORY
PROTECTION IN CONFINED OR ENCLOSED SPACES, IF NEEDED.
Ventilation:USE LOC EXHST TO CAPTURE VAP/MISTS/FUMES, IF NEC. PROVIDE
VENT SUFFICIENT TO PVNT EXCEEDING RECOM EXPOS LIM/ (ING 14)
Other Protective Equipment:CHEM-RESIST APRON/OTHER IMPERVIOUS CLTHG, IF
NEC, TO AVOID CONTAM REG CLTHG, WHICH COULD RSLT IN PRLNG/RPTD SKIN
CONT.
Work Hygienic Practices:REMOVE CONTAM CLTHG; LAUNDER/DRY-CLEAN BEFORE
RE- USE. REMOVE CONTAM SHOES & THORO CLEAN BEFORE RE-USE; DISCARD
(ING 15)
Supplemental Safety and Health
EXTING MEDIA:INVOLVING THIS TYPE OF PROD, DEPENDING ON SIZE/POTNTL SIZE
OF FIRE & CIRCUMSTANCES RELATED TO SITUATION. PLAN FIRE PROT &
RESPONSE STRATEGY THRU CONSULTATION W/LOC FIRE PROT AUTHS/ APPROP
SPECIALISTS. FIRE FIGHT:VAPS & TO PROVIDE PROT FOR MEN ATTEMPTING
TO STOP LEAK. H2O SPRAY MAY BE USED TO FLUSH (ING 2)
================== Physical/Chemical Properties ==================
HCC:V6
Boiling Pt:B.P. Text:396F,202C
Melt/Freeze Pt:M.P/F.P Text:21.2F,-6.0C
Vapor Pres:<5 @ 20C
Vapor Density:>5
Spec Gravity:0.85 @ 15.6C
pH:NEUT
Evaporation Rate & Reference:<0.01 (N-BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE (<0.1%)
Appearance and Odor:CLEAR WATER-WHITE LIQUID; MILD KEROSENE ODOR.
Percent Volatiles by Volume:NEGLIG
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONT W/STRONG OXIDANTS SUCH AS LIQ CHLORINE, CONC O2, SODIUM
HYPOCHLORITE/CALCIUM HYPOCHLORITE.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:FUMES, SMOKE, CO, SOX, ALDEHYDES &
OTHER DECOMP PRODS, IN CASE OF INCOMPLETE COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:1012/5012/5014 DRY INK CARTRIDGE,P/N 6R275
Preparer's Name:NONE
CAGE:0E6G9
CAGE:0E6G9
CAGE:6U221
CAGE:26921
============= Composition/Information on Ingredients =============
Ingred Name:STYRENE/ACRYLATE POLYMER
CAS:25767-47-9
Fraction by Wt: 45-50%
Other REC Limits:NONE RECOMMENDED.
Ingred Name:IRON OXIDE
CAS:1309-38-2
RTECS #:OM4800000
Fraction by Wt: 45-50%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 MG FE/M3 TDUST
ACGIH TLV:5 MG FE/M3 FUMES9394
Ingred Name:POLYPROPYLENE WAX
CAS:9003-07-4
RTECS #:UD1842000
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:QUATERNARY AMMONIUM SALT
CAS:102561-46-6
Fraction by Wt: 1-3%
Other REC Limits:NONE RECOMMENDED
Ingred Name:AMORPHOUS SILICA (SILICA GEL)
CAS:112945-52-5
RTECS #:VV7310000
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:6 MG/M3
ACGIH TLV:10 MG/M3 TDUST 9394
Ingred Name:AMORPHOUS SILICA
CAS:112945-86-9
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT) IS >5 G/KG.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES: NON-IRRITATING. SKIN: NOT
AN IRRITANT NOR A SENSITIZER. INHALATION: NON-TOXIC. CHRONIC: NONE
SPECIFIED.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:MINIMAL RESPIRATORY TRACT IRRITATION MAY OCCUR
AS WITH EXPOSURE TO LARGE AMOUNTS OF ANY NON-TOXIC DUST.
Medical Cond Aggravated by Exposure:NONE WHEN USED AS DESCRIBED BY
PRODUCT LITERATURE.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH LARGE AMOUNTS OF WATER. SKIN: WASH AREA WITH
SOAP AND WATER. INHALATION: MOVE TO FRESH AIR. INGESTION: DILUTE
STOMACH CONTENTS WITH SEVERAL GLASSES OF WATER.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER, DRY CHEMICAL, CARBON DIOXIDE, FOAM.
Fire Fighting Procedures:AVOID INHALATION OF SMOKE. WEAR PROTECTIVE
CLOTHING AND SELF CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:TONER IS A COMBUSTIBLE POWDER. LIKE MOST
ORGANIC MATERIALS IN POWDER FORM, WHEN DISPERSED IN AIR, IT CAN
FORM EXPLOSIVE MIXTURES.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP OR VACUUM SPILL AND CAREFULLY
TRANSFER INTO SEALABLE WASTE CONTAINER. SWEEP SLOWLY TO MINIMIZE
GENERATION OF DUST. IF VACUUM USED, MOTOR MUST BE RATED DUST TIGHT.
CONDUCTIVE HOSE BONDED TO MA CHINE SHOULD BE USED TO REDUCE STATIC
BUILDUP.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE.
Other Precautions:AVOID PROLONGED INHALATION OF EXCESSIVE DUST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED WHEN USED AS INTENDED.
Ventilation:USE ADEQUATE VENTILATION.
RESPIRATORS MAY BE REQUIRER IN BULK PROCESSING FACILITIES OF TONER.
Work Hygienic Practices:WASH AFTER HANDLING AND BEFORE EATING,
DRINKING, OR SMOKING.
Supplemental Safety and Health
NONE.
================== Physical/Chemical Properties ==================
HCC:V7
Spec Gravity:3
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLACK POWDER. FAINT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:PRODUCTS OF COMBUSTION MAY BE TOXIC.
AVOID BREATHING SMOKE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF WASTE IN ACCORDANCE WITH FEDERAL,
STATE, AND LOCAL REGULATIONS. WHEN DISPOSED, MATERIAL IS NOT A
HAZARDOUS WASTE ACCORDING TO FEDERAL REGULATION 40 CFR 261.
HOWEVER, STATE AND LOCAL REQUIRE MENTS MAY BE MORE RESTRICTIVE.
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:HYSOL EA 9394 PART B
Kit Part:Y
CAGE:33564
CAGE:33564
============= Composition/Information on Ingredients =============
Ingred Name:ALIPHATIC AMINES
Fraction by Wt: 60-100%
Ingred Name:AMORPHOUS FUMED SILICA, COLLOIDAL SILICON DIOXIDE,
AMORPHOUS SILICA DUST (IARC CARCINOGEN-GROUP 3) *96-2*
CAS:112945-52-5
RTECS #:VV7310000
Fraction by Wt: 5-10%
Other REC Limits:20 MPPCF DUST IN AIR
Ingred Name:VOLATILE ORGANIC CONTENT: <10 GM/L
RTECS #:9999999VO
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(RAT): 3160 MG/KG SILICA
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN/EYES: IRRITATION, CORROSIVE,
CHEMICAL BURNS. INHALATION: IRRITATION TO NOSE & THROAT.
REPEATED/PROLONGED SKIN CONTACT MAY CAUSE BURNS & POSSIBLE ALLERGIC
SENSITIZATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, CHEST DISCOMFORT, BURNS.
Medical Cond Aggravated by Exposure:SKIN SENSITIZATION.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR 15 MINS. SKIN: WASH THOROUGHLY W/SOAP
& WATER. INHALATION: REMOVE TO FRESH AIR. INGESTION: DRINK PLENTY
OF WATER. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:DRY CHEMICAL/HALON EXTINGUISHER, WATER SPRAY,
FOAM/FOG
Fire Fighting Procedures:WEAR SCBA & FULL PROTECTIVE CLOTHING.
CARTRIDGE RESPIRATORS DON'T PROVIDE ADEQUATE PROTECTION FOR
FIGHTERS/EXOTHERM MITIGATION.
Unusual Fire/Explosion Hazard:MAY LIBERATE LARGE QUANTITIES OF DENSE
FOUL-SMELLING SMOKE WHICH MAY CONTAIN UNIDENTIFIED TOXIC GASES.
================== Accidental Release Measures ==================
GLASSES. ABSORB W/SORBENT MATERIAL SUCH AS VERMICULITE/SAND. SCRAPE
UP/SHOVEL INTO DOT-APPROVED WASTE CONTAINERS.
======================Handling and Storage ======================
Handling and Storage Precautions:PRODUCT MAY BE STORED AT ROOM TEMP FOR
UP TO 12 MONTHS. KEEP CONTAINER TIGHTLY CLOSED WHEN NOT IN USE.
Other Precautions:EMPTY CONTAINER RETAIN PRODUCT RESIDUE SO OBEY
WARNINGS & HANDLE EMPTY CONTAINERS AS IF THEY WERE FULL. DON'T CUT,
GRIND, WELD/DRILL ON/NEAR THIS CONTAINER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF LOCAL EXHAUST VENTILATION IS INADEQUATE, A
RESPIRATOR EQUIPPED W/ORGANIC VAPOR CARTRIDGES MAY BE APPROPRIATE.
Ventilation:LOCAL EXHAUST VENTILATION AT THE POINT OF USE.
EYEWASH & SAFETY SHOWER.
Supplemental Safety and Health
CONDITIONS TO AVOID CONT'D: DON'T HEAT MIXED ADHESIVE >125F, UNLESS
CURING SURFACES TO BE BONDED. FAILURE TO OBSERVE RECAUTIONS MAY
CAUSE EXCESSIVE HEAT BUILDUP CAUSING AN EXOTHERM. THE EXOTHERM HAS
T HE POTENTIAL FOR RELEASE OF TOXIC GASES.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:644F
Vapor Pres:<0.01
Vapor Density:8.6
Spec Gravity:0.99
Viscosity:*
Solubility in Water:COMPLETE
Appearance and Odor:BLACK GEL W/AMINE ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG LEWIS/MINERAL ACIDS.
Stability Condition to Avoid:AVOID MIXING RESIN (A) & CURING AGENT (B)
IN BATCHES >1 LB. (SEE SUPP)
Hazardous Decomposition Products:CO, NITROGEN OXIDES, ALDEHYDES, ACIDS
& UNDETERMINED ORGANICS.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE IN AN EPA-APPROVED INCINERATOR.
DISPOSE OF IAW/FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CATHODE COATING BINDER B-209
Resp. Party Other MSDS Num.:T233B-207
Preparer's Name:M. E. HECHT
CAGE:FO444
CAGE:FO444
============= Composition/Information on Ingredients =============
Ingred Name:DIBUTYL PHTHALATE
CAS:84-74-2
RTECS #:TI0875000
< Wt:5.
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:ACETONE
CAS:67-64-1
RTECS #:AL3150000
> Wt:90.
OSHA PEL:2400 MG/M3;1000 PPM
ACGIH TLV:1780 MG/M3;750 PPM
ACGIH STEL:2380 MG/M3;1000 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:POLYMETHYLMETHACRYLATE; (METHYL METHACRYLATE)
CAS:9011-14-7
RTECS #:TR0400000
< Wt:5.
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:GASTROINTESTINAL DISTURBANCES. RENAL
AND HEPATIC INJURY HAVE RESULTED FROM OVEREXPOSURE. SKIN IRRITATION
FROM ITS DEFATTING ACTION. HEADACHE AND DIZZINESS FROM INHALATION.
RESPIRATORY IRRITATION.
Effects of Overexposure:SEE HEALTH HAZARDS.
======================= First Aid Measures =======================
First Aid:EYES: WASH THOROUGHLY FOR AT LEAST 15 MINUTES WITH LIDS
PULLED OPEN. CONTACT MD. SKIN: WASH CONTACT AREAS WITH SOAP AND
WATER FOR 15 MINUTES. INHALATION: REMOVE VICTIM TO FRESH AIR. APPLY
ARTIFICIAL R ESPIRATION IF BREATHING HAS STOPPED. INGESTION: DO NOT
INDUCE VOMITING.
===================== Fire Fighting Measures =====================
Extinguishing Media:DRY CHEMICAL, SPRAY FOG, CO*2 OR ALCOHOL FOAM.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . WATER SHOULD BE USED TO KEEP FIRE EXPOSED CONTAINERS
COOL. WATER MAY BE USED TO FLUSH SPILLS AWAY FROM EXPOSURE AND TO
DILUTE SPILLS TO NON- FLAMMABLE MIXTURES.
Unusual Fire/Explosion Hazard:EXPLOSION HAZARD WHEN VAPOR IS EXPOSED TO
FLAME IN CONFINED SPILL.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ANY SOURCE OF IGNITION. CONTAIN AND
ABSORB WITH CLAY OR VERMICULITE, FOLLOWED BY CONTAINMENT AND
DISPOSAL AS FLAMMABLE WASTE.
======================Handling and Storage ======================
Handling and Storage Precautions:ELECTRICAL EQUIPMENT SHOULD BE
SUITABLE FOR USE IN ATMOSPHERE CONTAINING METHYL METHACRYLATE
VAPORS. STORE IN A COOL PLACE AWAY FROM OXIDIZING MATERIALS. MUST
BE KEPT AWAY FROM FROM FLAMES OR IGNITION SOURCES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED RESPIRATOR WITH ORGANIC VAPOR
CARTRIDGE OR SELF-CONTAINED BREATHING APPARATUS.
Ventilation:LOCAL EXPLOSION - PROOF VENTILATION.
Other Protective Equipment:EYE WASH & DELUGE SHOWER MEETING ANSI DESIGN
CRITERIA . LAB COAT.
Supplemental Safety and Health
NOTE: PHYSICAL DATA PERTAINS TO ACETONE.
================== Physical/Chemical Properties ==================
Boiling Pt:=56.5C, 133.7F
B.P. Text:@ 1 ATM
Vapor Pres:180 @ 15C, MM HG @ 20C.
Vapor Density:2 (AIR=1)
Spec Gravity:0.79 (20/4C)
Solubility in Water:SOLUBLE
Appearance and Odor:COLORLESS, CLEAR LIQUID; FRAGRANT MINT LIKE ODOR.
Percent Volatiles by Volume:91
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CRC1*3, CHRONIC ANHYDRIDE, H*2O*2, HNO*3, CH*3, COOH.H*2SO*4,
K*2(CRO*4), OXIDIZING MATERIALS, ACIDS AND ALKALIES.
Stability Condition to Avoid:HEAT, SPARKS AND OPEN FLAME.
Hazardous Decomposition Products:VAPORS OF METHYL METHACRYLATE MAY FORM
POLYMERS.
Conditions to Avoid Polymerization:EXCESSIVE HEAT. METHYL METHACRYLATE
CONTAINS AN INHIBITOR TO PREVENT
=================== Toxicological Information===================
Toxicological Information:ACETONE: LD50:(ORAL,RABBIT) 5300 MG/KG.
DIBUTYL PHTHALATE CAS 84-74-2 TOXICITY (MG/M3): 8 G/KG.
==================== Disposal Considerations ====================
Waste Disposal Methods:SMALL QUANTITIES - EVAPORATE IN AN EXPLOSION
PROOF ENVIRONMENT. LARGE QUANTITIES - DISPOSE OF FLAMMABLE
HAZARDOUS WASTE I/A/W LOCAL, STATE AND FEDERAL REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:DOT CLASS: FLAMMABLE LIQUID, N.O.S. - UN1993.
===================== Regulatory Information =====================
SARA Title III Information:SARA SECTION 302 EHS RQ: REPORTABLE QTY OF
EXTREMELY HAZ SUBSTANCE, LISTED AT 40 CFR 355; ACETONE: NO (LBS);
DIBUTYL PHTHALATE: NO (LBS). SARA SECTION 302 EHS TPO: THRESHOLD
PLANNING QTY OF EXTREMELY HAZ SUBSTANCE. IF MATL IS SOLID & HAS
PARTICLE SITE EQUAL TO/LGR THAN 100 MICROMETERS, THRESHOLD PLANNING
QTY=10,000 LBS; ACETONE: NO (LBS); DIBUTYL PHTHALATE: NO (LBS).
SARA SECTION 313 CHEMS: TOX SU BSTANCES SUBJECT TO ANNUAL RELS
REPORTING REQUIREMENTS LISTED AT 40 CFR 372.65; ACETONE: NAME LIST
- YES, CHEM CATEGORY - NO; DIBUTYL PHTHALATE: NAME LIST - YES, CHEM
CATEGORY - NO.
Federal Regulatory Information:CERCLA SECTION 103: COMPREHENSIVE
ENVIRON RESPONSE, COMPENSATION & LIABILITY ACT (SUPERFUND). RELS TO
AIR, LAND/WATER OF THESE HAZ SUBSTANCE WHICH EXCEED REPORTABLE QTY
(RQ) MUST BE REPORTED TO THE NA TIONAL RESPONSE CENTER
(800-424-8802); LISTED AS 40 CFR 302.4. ACETONE: 5000 LBS; DIBUTYL
PHTHLATE: 10 LBS. RCRA: RESOURCE CONSERVATION & RECLAMATION ACT.
COMMERICAL CHEM PROD WASTES DESIGNATED AS ACU TE HAZARDS & TOXIC
UNDER 40 CFR 261.33. ACETONE: U002; DIBUTYL PHTHALATE: U069.
State Regulatory Information:
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CONFORMAL STAIN
CAGE:HO668
CAGE:HO668
============= Composition/Information on Ingredients =============
Ingred Name:BENZIN; (PETROLEUM NAPHTHA)
CAS:8030-30-6
RTECS #:DE3030000
OSHA PEL:500 PPM (MFR)
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION OF HIGH VAPOR
CONCENTRATION MAY CAUSE DIZZINESS, NAUSEA AND HEADACHE. REPEATED
SKIN CONTACT MAY CAUSE IRRITATION AND DERMATITIS. EYE CONTACT WILL
CAUSE BURNING AND IRRITATION. CHRONI C: NONE SPECIFIED BY
MANUFACTURER.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:GET MEDICAL ATTENTION IF SYMPTOMS PERSIST. INHAL: MOVE TO
FRESH AIR IF AFFECTED. EYES: FLUSH WITH WATER FOR AT LEAST 15
MINUTES. SKIN: WASH SKIN WITH SOAP AND WATER. INGEST: DO NOT INDUCE
VOMITING. CA LL A PHYSICIAN, GIVE EDIBLE OIL.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:107F,42C
Extinguishing Media:FOAM, CO*2, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . WATER SPRAY OR FOG OF VALUE, BUT MAY NOT EXTINGUISH.
Unusual Fire/Explosion Hazard:NO UNUSAL HAZARDS, HANDLE AS COMBUSTIBLE
LIQUID.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE IGNITION SOURCES. PICK UP WITH
ABSORBENT MATERIALS FOR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AS COMBUSTIBLE LIQUID.
Other Precautions:GROUND CONTAINERS WHEN TRANSFERRING OR DISPENSING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF TLV OF THE PRODUCT IS EXCEEDED, A NIOSH/MSHA
JOINTLY APPROVED AIR SUPPLIED RESPIRATOR IS ADVISED IN ABSENCE OF
PROPER ENVIRONMENTAL CONTROL.
Ventilation:LOCAL EXHAUST, MECHANICAL (GENERAL) EXPLOSION PROOF TO
ACHIEVE PEL.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:AVOID PERSONAL CONTACT.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:315F,157C
Vapor Pres:<20
Vapor Density:4.3
Spec Gravity:0.9 (H*2O=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:COLORED LIQUID, MILD ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:CARBON MONOXIDE FROM INCOMPLETE
COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF AS AN EPA IGNITABLE HAZARDOUS WASTE
IN ACCORDANCE WITH FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PRO-GARD STAY CLEAN
CAGE:0AHD1
CAGE:0AHD1
============= Composition/Information on Ingredients =============
Ingred Name:1,2,4-TRIMETHYLBENZENE (SARA 313)
CAS:95-63-6
RTECS #:DC3325000
Fraction by Wt: <6.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:25 PPM
ACGIH TLV:25 PPM; 9596
Ingred Name:XYLENES (O-,M-,P- ISOMERS) (SARA 313) (CERCLA)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: <3.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/150STEL;9596
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:MESITYLENE (TRIMETHYLBENZENES)
CAS:108-67-8
RTECS #:OX6825000
Fraction by Wt: <3.0%
Other REC Limits:NONE RECOMMENDED
Ingred Name:POLYETHER AMINE IN INGRED #2.
Other REC Limits:NONE RECOMMENDED
Ingred Name:NAPHTHA, LIGHT AROMATIC (SOLVENT NAPHTHA)
CAS:64742-95-6
RTECS #:WF3400000
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE:SLIGHT IRRIT,PROL IMPAIRMENT OF
VISION.DEGREE OF INJURY DEPEND ON AMT OF MATL/SPEED OF
1STAID.SKIN:SEVERE IRRIT,PROL INJURY.DEGREE OF INJURY DEPEND ON AMT
OF MATL/SPEED 1STAID.SKIN:PRACTICALLY NON -TOXIC TO INTERN
ORG.INHAL:PROL INHAL CNS EFFECTS.INGEST:SLIGHTLY TOXIC TO INTERN
ORG.ASPIRATION HAZ,SEVERE LUNG(SUPPLE)
Effects of Overexposure:EYE:PAIN,TEARS,SWELLING,REDNESS,BLURRED
VISION.SKIN:PAIN,FEELING OF
HEAT,DISCOLORATION,SWELLING,BLISTERING.INHAL:CNS
EFFECTS-HEAD,DIZZ,LOSS OF APPETITE,WEAK,LOSS OF
COORDINATION.INGEST:Medical Cond Aggravated by Exposure:NONE
SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH IMMED W/WATER FOR @LEAST 15MINS OPENING
EYELIDS.REMOVE CONTACT LENSES IF WORN.IRRIT PERSISTS SEE
DR.SKIN;REMOVE CONTAMIN CLOTH.WASH WELL W/SOAP/WATER.SIGNS/SYMPT
OCCUR SEE DR.INHAL:SIGNS/SYM PT OCCUR MOVE TO FRESH AIR.EFFECTS
CONTSEE DR.INGEST:GIVE WATER/MILK TO DRINK.CALL FOR MED
ADVICE.DON'T INDUCE VOMIT UNLESS DIRECTED BY MED PERSON.TAKE TO MED
EMERG TREAT CNTR W/PROD CNTNR(SUPPLEMEN)
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:100F,38C
Autoignition Temp:Autoignition Temp Text:660F
Lower Limits:NO DATA AVAI
Upper Limits:NO DATA AVAI
Extinguishing Media:CO2, DRY CHEMICAL, FOAM, WATER FOG.
Fire Fighting Procedures:FIRE INVOLVING MATL DO NOT ENTER ANY
ENCLOSED/CONFINED FIRE SPACE W/O PROPER PROTECTIVE EQPMT INCLUDING
SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:LIQ EVAPORATES/FORMS VAP(FUMES)WHICH CAN
CATCH FIRE/BURN W/EXPLO VIOLENCE.INVISIBLE VAP SPREADS EASILY-CAN
BE SET ON FIRE BY IGN SOURCES.FIRE HAZ >LIQ TEMP(SUP)
================== Accidental Release Measures ==================
Spill Release Procedures:MATL MAY BE TOXIC TO AQUATIC ORGANISMS,SHOULD
BE KEPT OUT OF SEWAGE/DRAINAGE SYS/BODIES OF WATER.STUDY AIR
POLLUTION REGS.ELIMINATE ALL OPN FLAM.STOP LEAD/SPILL.CLEANUP
ASAP,USE PPE.CONTAIN LIQ-PREVEN T CONTAM SOIL/WATER.FOLLOW
REPORTING PROCEDURES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:USE ONLY IN WELL VENTIL AREA.KEEP CNTNR CLSD.REPLACE
CAP/BUNG.EMPTIED CNTNR STILL CONTAINS HAZ/EXPLO
VAP/LIQ.READ/OBSERVE ALL PRECAUTIONS ON PRODUCT LABEL.READ ENTIRE
DOC/LABEL BEF USING PROD.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:MATL MAY BE INHAL HAZ & UNLESS VENTILATION IS
ADEQUATE THE USE OF APPROVED RESPIRATORY PROTECTION IS RECOMMENDED.
Ventilation:USE THIS MATL ONLY IN WELL VENTILATED AREAS.
Other Protective Equipment:PROTECTIVE CLOTHING.
Work Hygienic Practices:DISCARD CONTAMIN NON-WATERPROOF
SHOES/BOOTS.WASH CONTAMIN CLOTH.DON'T GET IN EYES/SKIN/CLOTH.
Supplemental Safety and Health
FIRE/EXPLO HAZ:RISES >85F. HEALTH HAZ:INJURY,DEATH.
1STAID:DR:INGEST/VOMIT CAN RESULT IN ASPIRATION OF LIGHT
HYDROCARBON LIQ-CAN CAUSE PNEUMONITIS.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:N/DATA AVAI
Melt/Freeze Pt:M.P/F.P Text:NA
Decomp Temp:Decomp Text:NP
Vapor Pres:0.59PSI
Vapor Density:NDA
Spec Gravity:0.85
pH:NP
Viscosity:1.6CST @40C
Evaporation Rate & Reference:NO DATA AVAILABLE.
Solubility in Water:INSOLUBLE.
Appearance and Odor:CLEAR COLORLESS TO PALE YELLOW LIQUID.
Percent Volatiles by Volume:NDN
Corrosion Rate:NP
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MAY REACT W/STRONG OXIDIZIGN AGENTS SUCH AS
CHLORATE,NITRATES,PEROXIDES,ETC.
Stability Condition to Avoid:DON'T USE/STORE NEAR FLAM/SPARK/HOT
SURF.DON'T WELD/HEAT/DRILL CNTNR.CAUT:DON'T USE PRESSURE TO EMPTY
DR-EXPLO MAY RESUL
Hazardous Decomposition Products:NA.COMBUST PROD:NORMAL COMBUST FORMS
CO2,WATER VAP,MAY PRODUCE OXIDES OF NITROGEN.INCOMPLETE COMBUST CAN
PRODUCE CO.
==================== Disposal Considerations ====================
Waste Disposal Methods:PLACE CONTAM MATLS IN DISPO CNTNRS/DISPO IN
MANNER CONSISTENT W/APPLICABLE REGS.CONTACT LOC ENVIRO/HEALTH
AUTHORITIES FOR APPROVED DISPO OF MATL.CONTAIN CHEMS SUBJ TO
REPORTING REQMTS SEC 313 TITLE II I SARA/40CFR372.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:GRC EP GL-4 140
Preparer's Name:DELNO D MALZAHN
CAGE:46684
CAGE:46684
============= Composition/Information on Ingredients =============
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATES, HYDROTREATED (SEVERE)
HEAVY NAPHTHENIC; (SEVERELY HYDROTREATED HEAVY (ING 2)
CAS:64742-52-5
RTECS #:PY8035001
Fraction by Wt: >99%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ING 1:NAPHTHENIC DISTILLATE)
RTECS #:9999999ZZ
Ingred Name:ADDITIVES CONTAINING POLYMERS
Fraction by Wt: <1%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPDAT:WE ARE ADVISING THAT ONE/MORE OF LISTED CHEMS MAY BE
PRESENT IN SOME DETECTABLE QTYS. READ & FOLLOW (ING 5)
RTECS #:9999999ZZ
Ingred Name:ING 4:DIRECTIONS AND USE CARE WHEN HANDLING THESE PETROLEUM
PRODUCTS.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC:THAN HIPS TO PREVENT ASPIRATION.
RTECS #:9999999ZZ
Ingred Name:VENT:OXYG DEFICIENT ATM, PARTICULARLY IN A CONFINED SPACE.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:THIS PROD HAS NOT BEEN TESTED AS A
WHOLE TO DETERM ITS SPECIFIC HLTH HAZARDS. INFO PROVIDED IN THIS
SECTION IS BASED ON HLTH HAZARD INFO ON PROD COMPONENTS.
ACUTE:EYES:MILDLY IRRITATING. SKIN:MAY SLIG HT IRRITATION.
INHALATION:NEGLIGIBLE TOMINIMALLY IRRITATING IF AIRBORNE
CONCENTRATIONS ARE KEPT BELOW (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:PERMISSIBLE OCCUPATIONAL EXPOSURE
LIMITS. INGESTION:INGEST OF LG AMTS MAY CAUSE HEADACHE, DROWSINESS,
NAUS, VOMITING/DIARRHEA. ASPIR HAZARD IF VOMITING OCCURS.
CHRONIC:FREQUENT/PROLONGED CONT MAY CAUSE SKIN IRRIT. RPTD EXCESS
EXPOSURE TO MIST MAY CAUSE PULM IRRIT/CHRONIC BRONCHITIS. ADDNL MED
AND (SUPDAT)
Medical Cond Aggravated by Exposure:MAY AGGRAVATE PRE-EXISTING
DERMATITIS.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH THORO W/WATER FOR @ LEAST 15 MINS, INCLDG UNDER
EYELIDS. CONT PHYS IMMED, PREFERABLY AN OPHTHALMOLOGIST IF
REDNESS/IRRIT OCCURS. SKIN:REMOVE CONTAMD CLTHG. WASH AFFECTED
AREAS W/SOAP & WATER . IF IRRIT OCCURS, GET MED HELP. INHAL:REMOVE
TO FRESH AIR. IF BRTHG HAS STOPPED APPLY ARTF RESP. GET IMMED MED
ATTN. INGEST:DO NOT INDUCE VOMIT. IF SPONT VOMIT OCCURS HOLD
VICTIM'S HEAD (ING 6)
===================== Fire Fighting Measures =====================
Flash Point:500F,260C
Extinguishing Media:DRY CHEMICAL, FOAM, CARBON DIOXIDE, OR WATER SPRAY.
Fire Fighting Procedures:USE NIOSH APPRVD SCBA & FULL PROTECTIVE
EQUIPMENT . WATER SPRAY MAY BE INEFTIVE ON FLAMES BUT SHOULD BE
USED TO KEEP FIRE-EXPOSED CONTAINERS COOL.
Unusual Fire/Explosion Hazard:MAY IGNITE WHEN SUFFICIENT HEAT IS
APPLIED.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE SOURCES OF HEAT/IGNIT INCLDG INTERNAL
COMBUST ENGINES & POWER TOOLS. REMOVE SPILL W/VACUUM TRUCKS OR PUMP
& SOAK UP RESIDUE WITH ABSORBENT. USE NIOSH APPRVD RESP WHERE OCCUP
EXPOSURE LIMITS MAY BE EXCEEDED.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN TIGHTLY CLOSED CONTAINERS IN
A DRY, COOL PLACE, AWAY FROM SOURCES OF HEAT, IGNITION OR STRONG
OXIDIZERS.
Other Precautions:GROUND AND BOND ALL TRANSFER AND STORAGE EQUIPMENT
AND EQUIP WITH SELF CLOSING VALVES, PRESSURE VACUUM BUNGS AND FLAME
ARRESTORS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE A NIOSH APPRVD RESP PROT EQUIP FOR CLEANING
LG SPILLS/ENTRY INTO LG TANKS, VESSELS/OTHER CONFINED SPACES/IN
SITUATIONS WHERE EXPOSURE MAY EXCEED OCCUP EXPOSURE LEVLES.
Ventilation:PROVIDE ADEQ GEN & LOC EXHAUST VENT:(1) TO KEEP MIST/VAPS
BELOW OCCUP EXPOSURE LEVS; (2) TO PVNT FORMATION OF AN (ING 7)
Other Protective Equipment:ANSI APPRVD EMER EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:REMOVE CONTACT LENSES. WASH W/SOAP & WATER
BEFORE EATING, DRINKING/SMKNG. LAUNDER CONTAMD CLTHG BEFORE REUSE.
Supplemental Safety and Health
EFTS OF OVEREXP:TOX INFO:IARC HAS DETERM THAT THERE IS SUFFICIENT EVID
FOR CARCIN OF USED OILS IN EXPERIMENTAL ANIMALS. CHEMS KNOWN TO ST
OF CA TO CAUSE CANCER, BIRTH DEFECTS/OTHER REPROD HARM MAY BE
FOUND IN PETRO PRODS. ALTHOUGH IT IS POSS TO SUFFICIENTLY REFINE
PETRO PRODS TO REMOVE POTNTL FOR CANCER, (ING 4)
================== Physical/Chemical Properties ==================
Spec Gravity:0.934 (H*2O)
Solubility in Water:NIL
Appearance and Odor:DARK BROWN LIQUID, SLIGHT HYDROCARBON ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, HEAT, SPARK, FLAME AND BUILD-UP OF STATIC
ELECTRICITY.
Stability Condition to Avoid:STRONG OXIDIZING AGENTS, HEAT, SPARK,
FLAME AND BUILD-UP OF STATIC ELECTRICITY.
Hazardous Decomposition Products:HYDROGEN SULFIDE, CARBON MONOXIDE,
CARBON DIOXIDE, ALDEHYDES, KETONES, & COMBUSTION PRODUCTS OF SULFUR
& NITROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF THROUGH A LICENSED WASTE DISPOSAL
COMPANY. FOLLOW FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:569 FAST DIAZO RESIN SENSITIZER
CAGE:ULANO
CAGE:53176
CAGE:ULANO
============= Composition/Information on Ingredients =============
Ingred Name:NON-HAZARDOUS FOR INGREDIENTS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: IRRITATION. INHALATION: MUCOUS
MEMBRANE IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SKIN: IRRITATION. INHALATION: MUCOUS MEMBRANE
IRRITATION.
======================= First Aid Measures =======================
First Aid:SKIN: WASH W/WATER. INHALATION: REMOVE TO FRESH AIR. OBTAIN
MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:CO2 OR FOAM
================== Accidental Release Measures ==================
Spill Release Procedures:WASH DOWN W/WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP IN COOL DRY AREA. EXPOSURE TO
LIGHT WILL CAUSE DECOMPOSITION OF DIAZO RESIN.
Other Precautions:MIX UNDER YELLOW OR SUBDUED LIGHT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:DUST FILTER FOR LARGE QUANTITIES.
Ventilation:MECHANICAL
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:244F
Solubility in Water:SOLUBLE
Appearance and Odor:YELLOW POWDER
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:LIGHT & HEAT
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:BLACK JACK PLASTIC CMT WET/DRY
CAGE:33394
CAGE:33394
============= Composition/Information on Ingredients =============
Ingred Name:STODDARD SOLVENT
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 10-30%
OSHA PEL:500 PPM
ACGIH TLV:100 PPM; 9293
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CHRONIC: NONE KNOWN. ACUTE: SKIN:
PROLONGED/ REPEATED CONTACT MAY CAUSE IRRITATION. EYES: MAY CAUSE
IRRITATION, BLURRED VISION. INHAL: EXCESSIVE BREATHING OF HIGH
VAPOR CONCENTRATIONS CAN CAUSE NASAL AND RESPIRATORY IRRITATION,
DIZZINESS, NAUSEA, POSSIBLE UNCONSCIOUSNESS AND EVEN ASPHYXIATION.
(SEE EFTS OF OVEREXPOS)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: INGEST: CAN CAUSE GASTROINTESTINAL
IRRITATION, NAUSEA, VOMITING AND DIARRHEA. ASPIRATION OF MATERIAL
INTO LUNGS CAN CAUSE CHEMICAL PNEUMONITIS WHICH CAN BE FATAL.
Medical Cond Aggravated by Exposure:PRE-EXISTING LUNG AND SKIN
DISORDERS.
======================= First Aid Measures =======================
First Aid:SKIN: WASH WITH SOAP AND WATER. EYES: FLUSH WITH LARGE
AMOUNTS OF WATER FOR AT LEAST 15 MINUTES. INHAL: REMOVE PERSON FROM
AFFECTED AREA. IF BREATHING IS DIFFICULT ADMINISTER OXYGEN. IF
BREATHING HAS STOPPED GIVE ARTIFICIAL RESPIRATION. INGEST: DO NOT
INDUCE VOMITING. SEEK MD IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:105F,41C
Lower Limits:7%
Upper Limits:0.8%
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICALS.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . WATER MAY CAUSE FROTHING, APPLY CAUTIOUSLY.
Unusual Fire/Explosion Hazard:KEEP AWAY FROM SOURCES OF IGNITION.
================== Accidental Release Measures ==================
Spill Release Procedures:DIKE SPILL AREA . RECOVER FREE LIQUID. ADD
ABSORBENT TO SPILL AREA. REMOVE SOURCES OF IGNITION. VENTILATE AREA
IF NECESSARY.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM SOURCES OF IGNITION.
USE ONLY WITH ADEQUATE VENTILATION. AVOID PROLONGED/REPEATED
CONTACT WITH SKIN.
Other Precautions:KEEP OUT OF THE REACH OF CHILDREN!
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NORMALLY NEEDED IN WELL VENTILATED AREA. IF
TLV IS EXCEEDED, A NIOSH/MSHA APPROVED BREATHING APPARATUS IS
RECOMMENDED.
Ventilation:AS NECESSARY TO MAINTAIN EXPOSURE BELOW TLV LEVEL.
Other Protective Equipment:AS NECESSARY.
Work Hygienic Practices:REMOVE CONTAMINATED CLOTHING, LAUNDER BEFORE
REUSE.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:300F,149C
Vapor Pres:2 (25C)
Vapor Density:>1
Spec Gravity:1.1
Evaporation Rate & Reference:<1 (BUAC=1)
Solubility in Water:NIL
Appearance and Odor:BLACK PASTE, SOLVENT ODOR.
Percent Volatiles by Volume:10-30
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:HEAT, SPARKS, FLAMES.
Hazardous Decomposition Products:CO2 AND CO.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF ACCORDING TO FEDERAL, STATE AND LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ISOLITE 862
CAGE:GO826
CAGE:GO826
CAGE:88577
============= Composition/Information on Ingredients =============
Ingred Name:1,2-BENZENEDICARBOXYLIC ACID, DI-2-PROPENYL ESTER; (DIALLYL
PHTHALATE)
CAS:131-17-9
RTECS #:CZ4200000
Fraction by Wt: 40-50%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PEROXIDE, BIS(ALPHA, ALPHA'-DIMETHYLBENZYL); DICUMYL
PEROXIDE
CAS:80-43-3
RTECS #:SD8150000
Fraction by Wt: 1-2%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SPILL PROC: REQD BY THE SIZE OF THE SPILL. DECONTAMINATE
THE AREA, COLLECTING ANY CLEANING & RINSING MEDIA FOR (ING 4)
RTECS #:9999999ZZ
Ingred Name:ING 3: PROPER RECLAMATION/DISPOSAL. DETERMINE APPROP COURSE
OF ACTION FOR THE COLLECTED MATL. CONTACT THE (ING 5)
RTECS #:9999999ZZ
Ingred Name:ING 4: APPROP AUTHORITIES & DISPOSE ACCORDING TO GOVT REGS.
PERSONS NOT WEARING APPROP PROT EQUIP & CLTHG SHOULD (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5: BE RESTRICTED FROM AREAS OF SPILLS UNTIL CLEANUP HAS
BEEN COMPLETED AS OUTLINED.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENTS
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ING 1: SKIN: MODERATE IRRITATION.
EYES: MILD IRRITATION. INGEST: MODERATELY TOXIC. INHAL: CONSIDERED
LACHRYMATORY & MODERATELY TOXIC. ING 2: SKIN: MILD IRRITATION &
W/PROLONGED CONTACT WILL CAUSE DERM ATITIS. EYES: MILD IRRITATION.
INGEST: HARMFUL IF SWALLOWED. INHAL: MAY CAUSE MILD RESPIRATORY
IRRITATION.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:ANY PREEXISTING ABNORMAL CONDITIONS
OF SKIN, EYE, RESPIRATORY SYSTEM AND/OR THE LIVER MAY BE AGGRAVATED
BY EXPOSURE TO THIS MATERIAL.
======================= First Aid Measures =======================
First Aid:MOVE PERSON FROM AREA. IF "OVERCOME" IMMED CNTCT MED AUTH &
IMPLEMENT APPROP EMER RESCUE PROC. USE PROT EQUIP AS NEC. EYES:WASH
IMMED W/LG AMTS H*2O FOR @ LEAST 15 MIN; LIFT LOWER & UPPER LIDS
OCCAS. IF IRRIT/CHEM BURNS, GET PROMPT MED ATTN. SKIN:WASH CONTAMD
SKIN W/H*2O. IF MATL PENETRATES CLTHG, REMOVE & FLUSH SKIN W/H*2O.
IF SIGNS OF SENSIT, IRRIT/CHEM BURNS GET PROMPT MED ATTN. INHAL:
(SUPDAT)
===================== Fire Fighting Measures =====================
Flash Point:329F,165C
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICALS, FOAM, FOG.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . EXCLUDE AIR; TREAT LIKE A GASOLINE OR OIL
FIRE.
Unusual Fire/Explosion Hazard:WHEN HEATED TO DECOMPOSITION IT MAY EMIT
TOXIC FUMES.
================== Accidental Release Measures ==================
Spill Release Procedures:STOP SOURCE OF SPILL & REMOVE ALL IGNIT
SOURCES. VENT AREA OF SPILL. CNTN SPILL & PVNT MATL FROM OBTAINING
ACCESS TO ANY CONFINED SPACES, PUBLIC SEWERS/WATERWAYS. COLLECT
MATL USING ABSORB, NON-SPK TO OLS, EXPLOS PROOF VACUUMS/OTHER EQUIP
(ING 3)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE MATERIAL IN COOL, VENTILATED,
DRY AREA (40-80F). KEEP CONTAINERS CLOSED WHEN NOT IN USE AND
GROUNDED AT ALL TIMES.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:APPROPRIATE NIOSH/MSHA APPROVED RESPIRATION
EQUIPMENT NEEDED IF CITED PEL/TLV LIMITS ARE EXCEEDED.
Ventilation:MAINTAIN VAPOR LEVELS BELOW CITED TLV OF EXPLOSION LIMITS
FOR HAZARDOUS MATERIALS.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER. EYE
Work Hygienic Practices:WEAR APPROPRIATE CLEAN, PROTECTIVE CLOTHING AND
KEEP CONTACT (BODY) AREAS CLEAN.
Supplemental Safety and Health
FIRST AID PROC: IF LG AMTS INHALED/BRTHG PROBS OCCUR, MOVE TO FRESH AIR
@ ONCE. IF BRTHG STOPPED, PERFORM ARTF RESP. KEEP PERSON WARM & @
REST WHILE GETTING MED ATTN. INGEST:GET PROMPT MED ATTN. IF NO T
IMMED AVAIL & PERSON CONSCIOUS, HAVE PERSON SWALLOW LG AMTS WATER
TO DILUTE MATL. DO NOT ATTEMPT TO MAKE PERSON VOMIT.
================== Physical/Chemical Properties ==================
Vapor Density:> AIR
Spec Gravity:1.170-1.190
Evaporation Rate & Reference:< ETHER
Solubility in Water:NO
Appearance and Odor:CLEAR AMBER LIQUID WITH CHARACTERISTIC ODOR OF
DIALLYL PHTHALATE.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID STRONG OXIDANTS.
Stability Condition to Avoid:AVOID ANY HEAT, SPARKS OR STATIC
ELECTRICITY.
Hazardous Decomposition Products:ON THERMAL DECOMPOSITION IT MAY EMIT
TOXIC FUMES, INCLUDING CARBON MONOXIDE AND/OR CARBON DIOXIDE.
Conditions to Avoid Polymerization:DURING CURING/REACTION PROCESS,
TOXIC BYPRODUCTS MAY BE EMITTED. DO NOT REROUTE VENTED GASES BACK
INTO THE WORK AREA.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTACT THE APPROPRIATE AUTHORITIES AND DISPOSE
ACCORDING TO FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:DEX-O-TEX MAGNABOND PASTE 1097
CAGE:88167
CAGE:88167
============= Composition/Information on Ingredients =============
Ingred Name:1,3-BUTADIENE, 2-CHLORO-; (CHLOROPRENE) (SARA III)
CAS:126-99-8
RTECS #:EI9625000
Fraction by Wt: <0.4%
OSHA PEL:S; 25 PPM
ACGIH TLV:S; 10 PPM; 9293
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:POTASSIUM HYDROXIDE (SARA III)
CAS:1310-58-3
RTECS #:TT2100000
OSHA PEL:2 MG/M3, C
ACGIH TLV:2 MG/M3, C
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Ingred Name:SODIUM SILICATE
CAS:1344-09-8
Ingred Name:SILICON EMULSION
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: MAY CAUSE IRREVERSIBLE DAMAGE
TO EYES. SKIN: IRRITATION OR RASH. CHRONIC: POSSIBLE IRREVERSIBLE
DAMAGE TO EYES.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NOT KNOWN.
======================= First Aid Measures =======================
First Aid:INHALATION: MOVE SUBJECT TO FRESH AIR. EYES: FLUSH WITH WATER
FOR AT LEAST 15 MINUTES. CALL PHYSICIAN AT ONCE. SKIN: WASH WITH
SOAP AND WATER. REMOVE CONTAMINATED CLOTHING. INGESTION: INDUCE
VOMITING AND CALL PHYSICIAN AT ONCE.
===================== Fire Fighting Measures =====================
Flash Point Method:TOC
Flash Point:>212F,>100C
Extinguishing Media:WATER, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . FOLLOW REGULAR PROCEDURES FOR EXTINGUISHING
FIRES.
Unusual Fire/Explosion Hazard:SUBSTANTIAL QUANTITIES OF HYDROGEN
CHLORIDE (TLV-5PPM) ARE EVOLVED WHEN NEOPRENE IS HEATED AT
TEMPERATURES OF 392F OR HIGHER.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH SPILL WITH EXCESS WATER TO CHEMICAL
SEWER OR SOAK UP WITH ABSORBENT MATERIAL. HAVE PROTECTIVE CLOTHING
AVAILABLE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL PLACE. AVOID FREEZING.
DO NOT HEAT ABOVE 200F.
THIS MATERIAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:HAVE NIOSH/MSHA APPROVED AIR SUPPLIED FACE MASK
IF TLV OF CHLOROPRENE IS EXCEEDED.
Ventilation:LOCAL OR MECHANICAL EXHAUST.
Other Protective Equipment:AS REQUIRED TO PREVENT SKIN CONTACT.
EMERGENCY EYEWASH AND DELUGE SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:220F,104C
Vapor Pres:AS WATER
Spec Gravity:1.1 (H*2O=1)
Evaporation Rate & Reference:AS WATER
Solubility in Water:COMPLETELY MISCIBLE
Appearance and Odor:MILKY WHITE LIQUID WITH CHARACTERISTIC ODOR
Percent Volatiles by Volume:50
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS WILL CAUSE COAGULATION OF LATEX.
Stability Condition to Avoid:AVOID FREEZING-IF RAW LATEX IS HEATED, IT
WILL FOAM AT 200F.
Hazardous Decomposition Products:HYDROGEN CHLORIDE (AT TEMPERATURES
ABOVE 392F).
==================== Disposal Considerations ====================
Waste Disposal Methods:SANITARY LANDFILL IN ACCORDANCE WITH LOCAL,
STATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ENAMEL, ALKYD, GLOSS LO VOC CT GREEN 14187
Preparer's Name:W A ELLISON
CAGE:FO127
CAGE:FO127
CAGE:61196
============= Composition/Information on Ingredients =============
Ingred Name:XYLENE (SOLVENT) (SARA III) (VAPOR PRESSURE 5 MM @ 20 C)
(LFL 1.0; UFL 7.0)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 10%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/150 PPM STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SOLVENT, NAPHTHA, LIGHT AROMATIC (SOLVENT)
CAS:64742-95-6
Fraction by Wt: <5%
Other REC Limits:NONE SPECIFIED
Ingred Name:N-BUTYL ACETATE (SOLVENT) (LFL 1.7; UFL 7.6) (VAPOR
PRESSURE 10 MM HG @ 20C)
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: 5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:150 PPM/200 PPM STEL
ACGIH TLV:150 PPM/200 PPM STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ETHYL BENZENE (SOLVENT) (SARA III) (LFL 1.0; UFL 6.7)
(SKIN) (VAPOR PRESSURE 1 MM HG @ 20C)
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: <5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:100 PPM/125 PPM STEL
ACGIH TLV:100 PPM/125 PPM STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:STODDARD SOLVENT (LFL .8)
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: <5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:500 PPM
ACGIH TLV:100 PPM; 9293
Ingred Name:TITANIUM DIOXIDE (PIGMENT)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:TRIMETHYL BENZENE (SARA III)
CAS:25551-13-7
RTECS #:DC3220000
Fraction by Wt: 5%
Other REC Limits:NONE SPECIFIED
OSHA PEL:25 PPM/125 MG/CU.M
ACGIH TLV:25 PPM/125 MG/CU.M
Ingred Name:1,2,4-TRIMETHYLBENZENE (SARA III)
CAS:95-63-6
RTECS #:DC3325000
Fraction by Wt: 5%
Other REC Limits:NONE SPECIFIED
Ingred Name:VOC: 2.98 LB/GL LESS WATER & NEGLIGIBLY PHOTOCHEMICALLY
REACTIVE MATERIALS; 358 G/L LESS WATER; CALCULATED
RTECS #:9999999VO
Other REC Limits:NONE SPECIFIED
Ingred Name:VOC: 5.07 LB/GAL SOLIDS; 608 G/L SOLIDS; CALCULATED
RTECS #:9999999VO
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:INGEST: GI IRRITATION. ASPIRATION OF
MAT'L INTO LUNG MAY CAUSE CHEM PNEUMONITIS WHICH CAN BE FATAL.
INHAL: NOSE/THROAT IRRITATION. HIGH CONC: CENTRAL NERV SYS DEPRESS.
EYE: SEVERE IRRITATION, CORNEAL DAMAGE. SKIN: DEFATTING &
IRRITATION. OVEREXPOSURE: LIVER, KIDNEY & BLOOD. PERMANENT BRAIN &
NERVOUS SYS DAMAGE. *
Explanation of Carcinogenicity:NO
Effects of Overexposure:INGEST: NAUSEA, VOMITING. INHAL: HEADACHE,
DIZZINESS, NAUSEA, CONFUSION.
* INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING &
INHALING CONTENTS MAY BE HA RMFUL OR FATAL. RAT: INCREASED
BENIGN/MALIGNANT LUNG TUMORS AT HIGH EXPOSURE LEVELS.
======================= First Aid Measures =======================
First Aid:INGEST: DON'T INDUCE VOMIT. CALL POISON CNTRL CTR, HOSP EMERG
RM/DR IMMED. INHAL: REMOVE TO FRESH AIR IMMED. BREATH STOPPED, GIVE
ARTIF RESPIRATION. KEEP WARM, QUIET. GET MED AID IMMED. EYE: FLUSH
W/W ATER, LIFT EYELIDS 15 MIN. GET MED AID.SKIN: REMOVE CONTAM
CLOTHES. WASH W/SOAP & WATER. NOTES TO DR: DIRECT ANY TREATMENT
THAT MIGHT BE REQ'D FOR OVEREXPOS AT SYMPTOMS CONTROL & CLINICAL
CONDITION.
===================== Fire Fighting Measures =====================
Flash Point:59.0F,15.0C
Autoignition Temp:Autoignition Temp Text:572F
Lower Limits:.8
Upper Limits:7.6
Extinguishing Media:USE NFPA CLASS B EXTINGUISHERS (CO2, ALL PURPOSE
DRY CHEMICAL/ALCOHOL FOAM). POLYMER FOAM IS PREFERRED FOR LARGE
FIRES.
Fire Fighting Procedures:DURING EMERG CONDITIONS, OVEREXPOSURE TO
DECOMPOSITION PRODUCTS MAY CAUSE HEALTH HAZARD. SYMPTOMS MAY NOT BE
IMMEDIATELY APPARENT. OBTAIN MEDICAL ATTENTION.
Unusual Fire/Explosion Hazard:WATER MAY BE INEFFECTIVE, MAY USE (PREFER
FOG NOZZLES) TO COOL EXPOSED CNTNRS TO PREVENT PRESSURE BLDUP &
AUTOIGNITION/EXPLOSION WHEN EXPOSED TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR RESPIRATOR, EYE, HAND, BODY PROTECT FOR
SIZE OF SPILL/EXPOSURES ENCOUNTERED. EVACUATE SPECTATORS. ELIM
IGNIT SOURCES. DIKE/CONTAIN SPILL W/INERT MAT'L. TRANSFER LIQ TO
COVERED METAL CONTAINERS/RE MOVE W/ABSORB. USE NON-SPARKING TOOLS.
**
Neutralizing Agent:N/K ** PREVENT CONTAMINATION OF SEWERS, STREAMS,
GROUNDWATER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 115F. STORE LARGE
QUANTITIES IN COMPLIANCE W/OSHA 29CFR 1910.106. DON'T TAKE
INTERNALLY. CLOSE CONTAINER AFTER EACH USE.
Other Precautions:EMPTY CONTAINERS MUST NOT BE WASHED AND REUSED FOR
ANY PURPOSE. CONTAINERS SHOULD BE GROUNDED AND BONDED TO THE
RECEIVING CONTAINER. DO NOT WELD, BRAZE OR CUT ON EMPTY CONTAINER.
NEVER USE PRESSURE TO EMPTY. DRUM IS NOT A PRESSURE VESSEL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF WELL VENTED, RESPIRATOR MAY NOT BE REQ'D.
RESTRICTED VENT, NIOSH CHEM CARTRIDGE RSPRTR. CONFINED AREA,
NIOSH/MSHA AIR SUPPLIED RSPRTR. TLV'S EXCEEDED, FITTED NIOSH/MSHA
RSPRTR W/APPROP PROTECTION F ACTOR (SEE OSHA 29 CFR 1910.134).
Ventilation:LOCAL EXHAUST (VOL/PATTRN) TO MAINTAIN EXPOSURE BELOW
TLV/PEL.
Other Protective Equipment:EYEWASH FACILITY, SAFETY SHOWER.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:139 TO 390F
Melt/Freeze Pt:M.P/F.P Text:-50F,-45C
Decomp Temp:Decomp Text:1832F,1000C
Vapor Pres:10 @ 68F
Vapor Density:> AIR.
Spec Gravity:1.1
pH:4-7
Viscosity:67-77 KU
Evaporation Rate & Reference:SLOWER THAN DIETHYL ETHER
Solubility in Water:SLIGHT IN WATER.
Appearance and Odor:LIQUID, SOLVENT ODOR.
Percent Volatiles by Volume:41
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS OR ALKALINE MATERIALS. OXIDIZING MATERIALS.
Stability Condition to Avoid:AVOID EXCESSIVE HEAT (>115F) AND SOURCES
OF IGNITION.
Hazardous Decomposition Products:BURNING, INCLUDING WHEN HEATED BY
WELDING OR CUTTING, WILL PRODUCE SMOKE, CARBON MONOXIDE, AND CARBON
DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE W/FED, STATE, LOCAL LAWS.
INCINERATE IN EPA PERMITTED FACILITY. DON'T INCINERATE CLSD CNTNRS.
OBSERVE PRECAUTIONS FOR DISPOSAL IN HAZARDOUS WASTE LANDFILL.
DISPOSE ONLY IN ACCORD ANCE WITH FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:EA9323 PART A
Kit Part:Y
CAGE:0KZ46
CAGE:33564
CAGE:33150
CAGE:0KZ46
============= Composition/Information on Ingredients =============
Ingred Name:TRIGLYCIDYL P-AMINOPHENOL EPOXY RESIN
CAS:5026-74-4
Fraction by Wt: <55%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE SKIN IRRITATION AND POSSIBLE
ALLERGIC REACTIONS. PROLONGED AND REPEATED CONTACT MAY CAUSE
SENSITIZATION WHICH WILL RESULT IN ALLERGIC REACTIONS.
Effects of Overexposure:N/K *SURFACES TO BE BONDED. FAILURE TO
OBSERVE CAUTIONS MAY RESULT IN EXCESSIVE HEAT BUILD-UP WITH THE
RELEASE OF TOXIC GASES.
======================= First Aid Measures =======================
First Aid:FLUSH SKIN AND EYE CONTACT WITH PLENTY OF WATER. WASH SKIN
THOROUGHLY WITH SOAP AND WATER, RUBBING ALCOHOL OR HAND CLEANER. DO
NOT USE SOLVENTS. REMOVE SOILED CLOTHING AND WASH BEFORE REUSE. IF
IRRITA TION PERSISTS OR INCREASES, SEE PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:>300F,>149C
Extinguishing Media:DRY CHEMICAL OR HALON FIRE EXTINGUISHER, WATER
SPRAY, FOAM OR FOG.
Fire Fighting Procedures:USE SELF-CONTAINED BREATHING APPARATUS WHEN
FIGHTING FIRES IN CONFINED AREAS.
Unusual Fire/Explosion Hazard:DENSE SMOKE AND TOXIC GASES MAY BE
LIBERATED.
================== Accidental Release Measures ==================
GLASSES. SCRAPE UP AND TRANSFER TO METAL CONTAINER. WIPE UP
REMAINING RESIDUE WITH SOLVENTS, OBSERVING SOLVENT FLAMMABILITY
CAUTIONS OR USE DETERGENT.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP PRODUCT COOL IN ACCORDANCE WITH
LABEL INSTRUCTIONS.
Other Precautions:FOLLOW RECOMMENDED CURING SCHEDULE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED WITH GOOD INDUSTRIAL VENTILATION.
Ventilation:LOCAL EXHAUST: RECOMMENDED. MECHANICAL: RECOMMENDED.
Other Protective Equipment:AS NEEDED TO PROTECT SKIN AND CLOTHING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:DECOMPOSES
Vapor Pres:<0.01 MM
Vapor Density:NIL
Spec Gravity:>1
Evaporation Rate & Reference:NIL
Solubility in Water:NIL
Appearance and Odor:TAN PASTE WITH SLIGHT CHARACTERISTIC ODOR.
Percent Volatiles by Volume:<0.01
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG LEWIS OR MINERAL ACIDS.
Hazardous Decomposition Products:CO, NOX, ALDEHYDES, ACIDS AND
UNDETERMINED ORGANICS.
Conditions to Avoid Polymerization:AVOID MIXING RESIN/CURING AGENT IN
BATCHES GREATER THAN 1 LB. DO NOT HEAT MIXED ADHESIVE ABOVE 75F
UNLESS CURING *
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF AS HAZARDOUS WASTE ACCORDING TO
D.O.T. HAZARD CLASS. IF NOT REGULATED BY D.O.T., DISPOSE OF AS
ORM-E. DISPOSAL METHOD CAN BE LAND BURIAL OR CHEMICAL INCINERATION
AS REGULATED BY ALL GOVERNM ENTAL AGENCIES.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:DRO76-CONCENTRATE
CAGE:EO559
CAGE:EO559
CAGE:70506
============= Composition/Information on Ingredients =============
Ingred Name:ALIPHATIC NAPHTHA
Fraction by Wt: 25.0%
ACGIH TLV:400 PPM
Ingred Name:XYLENE SUBSTITUTE
Fraction by Wt: 58.0%
ACGIH TLV:150 PPM
Ingred Name:N-BUTYL ACETATE (SARA III)
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: 16.0%
OSHA PEL:150 PPM/200 STEL
ACGIH TLV:150 PPM/200STEL;9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: <5.0%
OSHA PEL:200 PPM/300 STEL
ACGIH TLV:200 PPM/300STEL 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TRIETHYLAMINE (SARA III)
CAS:121-44-8
RTECS #:YE0175000
Fraction by Wt: <5.0%
OSHA PEL:25 PPM/15 STEL
ACGIH TLV:10 PPM/15 STEL; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Effects of Overexposure:INHALATION- HEADACHE, NAUSEA, DIZZINESS.
PROLONGED OR REPEATED CONTACT MAY CAUSE SKIN IRRITATION.
======================= First Aid Measures =======================
First Aid:INHALATION-MOVE TO FRESH AIR. SKIN CONTACT-FLUSH WITH LARGE
AMOUNT OF WATER. REMOVE CONTAMINATED CLOTHING. EYE CONTACT-FLUSH
WITH CLEAN WATER FOR AT LEAST 15 MIN.-CALL PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:58F-14.4C PMCC
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM
Fire Fighting Procedures:SELF-CONTAINED BREATHING APPARATUS SHOULD BE
WORN BY FIREMEN
Unusual Fire/Explosion Hazard:USE WATER TO COOL CONTAINERS EXPOSED TO
FIRE
================== Accidental Release Measures ==================
Spill Release Procedures:AVOID BREATHING VAPORS, EXTINGUISH IGNITION
SOURCES IN AREA. AVOID CONTACT WITH LIQUID.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE AT ELEVATED TEMPERATURES.
Other Precautions:CLOSE CONTAINERS AFTER USE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IN CONFINED AREA USE U.S. BUR. OF MINES APPROVED
RESPIRATOR
Ventilation:LOCAL-SUFFICIENT TO KEEP CONCENTRATION BELOW GIVEN TLV
Other Protective Equipment:NORMAL PROTECTIVE CLOTHING
Supplemental Safety and Health
BOILING POINT: 80-125.5C
================== Physical/Chemical Properties ==================
HCC:V3
Boiling Pt:B.P. Text:176-258 F
Vapor Density:>1.0
Spec Gravity:1.03
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:SLIGHT
Appearance and Odor:MOBILE LIQUID CONTAINING VOLATILE SOLVENTS. YELLOW
Percent Volatiles by Volume:75.9
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIALS SOFTENS RUBBER
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN CLOSED CONTAINERS AWAY FROM
IGNITION SOURCES.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CHLORPROMAZINE HYDROCHLORIDE, THORAZINE
CAGE:SMITH
CAGE:93544
CAGE:SMITH
============= Composition/Information on Ingredients =============
Ingred Name:PHENOTHIAZINE, 2-CHLORO-10-(3-(DIMETHYLAMINO)
PROPYL)-MONOHYDROCHLORIDE; (CHLORPROMAZINE HYDROCHLORIDE)
CAS:69-09-0
RTECS #:SO1750000
Fraction by Wt: >98%
OSHA PEL:0.04 MG/M3 (MFR)
Ingred Name:SUPP DATA: DEFECTS)/OTHER ADVERSE EFTS ON DEVELOPING
OFFSPRING CAN OCCUR, BASED ON ANIMAL STUDIES. USE OF MATL (ING 3)
RTECS #:9999999ZZ
Ingred Name:ING 2: IS NOT RECOM BY PREGNANT WOMEN. OTHER EFTS: THIS
MATL IS USED AS A TRANQULIZER & ANTIEMETIC.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC: OF TOX DEVELOP MANY HRS AFTER EXPOS.
INGEST: SEEK IMMED MED ASSISTANCE. DO NOT INDUCE VOMIT (ING 5)
RTECS #:9999999ZZ
Ingred Name:ING 4: BECAUSE OF POSSIBILITY FOR NECK MUSCLE SPASMS
LEADING TO ASPIR OF VOMITUS. EARLY GASTRIC LAVAGE IS (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5: RECOM. NOTE TO PHYS: SUBJECT MAY EXPER
EXTRAPYRAMIDAL SYMP. IN CASE OF OVEREXP, REFER TO MOST (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6:RECENT EDITION OF PHYS DESK REFERENCE FOR TREATMENT
OF PHENOTHIAZINE OVERDOSAGES.
RTECS #:9999999ZZ
Ingred Name:SPILL PROC: DAMPEN MATL TO REDUCE CHANCES FOR DUST
EXPOSURE.
RTECS #:9999999ZZ
Ingred Name:OTHER PROT EQUIP: WASH STATION SHOULD BE READILY AVAILABLE.
RTECS #:9999999ZZ
Ingred Name:HYGIENE PRACT: SPILLS IMMEDIATELY.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(ORAL,RAT)141 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: ASSUME DIRECT CONT CAN PRDCE GEN
TOX/IRRIT. SYMP OF GEN TOX MIGHT INCL DROW, MUSCLE
TREMORS/RIGIDITY, STUPOR, COMA & DEATH IN EXTREME CASES. AFTER
CHRONIC EXPOS, SYMP MIGHT INCL LIVER DAM, TREMO RS, DERM & EFTS ON
EYES. SYMP IF IRRIT SUCH AS RED/SWELL MIGHT BE IMMED/DELAYED. EYE:
SEV IRRIT CAN (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:OCCUR FOLLOW DIRECT CONT. SERIOUS EYE
DAM IS POSS. INHAL:DUST CAN BE HARMFUL IF INHALED, POSS FATAL @
HIGH CONC BASED ON ANIMAL STUDIES. SYMP MIGHT INCL DROW, MUSCLE
TREMORS/RIGIDITY, STUPOR, COMA & DEATH IN EXTREME CASES. AFTER
CHRONIC EXPOS, SYMP MIGHT INCL LIVER DAM/TREMORS, DERM & EFTS ON
EYES. (SUPP DATA)
Medical Cond Aggravated by Exposure:INDIVIDUALS W/HEART PROBLEMS MAY BE
SENSITIVE TO CARDIOVASCULAR EFTS OF MATL. DEPRESSANT EFTS OF
ALCOHOL & DRUGS SUCH AS BARBITURATES CAN BE ENHANCED BY THIS
MATERIAL.
======================= First Aid Measures =======================
First Aid:SKIN: REMOVE CONTAMD CLTHG, WASH EXPOSED AREA W/SOAP/H*2O.
OBTAIN MED ASSISTANCE IF IRRIT OCCURS, EVEN IF DELAYED. IF
PHOTOSENSITIVITY DEVELOPS, AVOID DIRECT SUNLIGHT. EYE: WASH W/H*2O
FOR @ LST 30 MI N THEN SEEK MED ASSISTANCE. INHAL: MOVETO FRESH
AIR. SEE PHYS IF SUBJECT EXPER DFCLTY BRTHG. IF BRTHG HAS STOPPED,
PERFORM CPR & OBTAIN IMMED MED ASSISTANCE. SEEK MED ASSISTANCE IF
SYMP OF (ING 4)
===================== Fire Fighting Measures =====================
Flash Point:>131F,>55C
Extinguishing Media:USE WATER, CO*2, FOAM OR DRY POWDER SUITABLE FOR
SURROUNDING FIRE.
Fire Fighting Procedures:NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP.
TOX/CORR GASES INCL CO*X, NO*X & SO*X TOGETHER W/CHLORINE & HCL ARE
EXPECTED IN FIRES INVOLVING (SUPP DATA)
Unusual Fire/Explosion Hazard:MATL IS SLIGHTLY COMBUST. LIKE MOST ORG
DUSTS, IT IS EXPECTED TO EXPLODE WHEN IGNITED AS A DUST CLOUD. CARE
SHOULD BE TAKEN TO AVOID DISPERSION AS A DUST CLOUD.
================== Accidental Release Measures ==================
Spill Release Procedures:RESTRICT ENTRY UNTIL AREA IS THORO CLEANED.
WEAR SUITABLE PROT CLTHG TO AVOID BRTHG DUST, EYE/SKIN CONT. FOR
SPILLS OF DRY POWDER, USE A CLEAN SHOVEL & PLACE MATL INTO CLEAN,
DRY CONTRS THEN COVER. MO VE CONTRS AWAY FROM SPILL AREA. IF POSS,
(ING 7)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM MOISTURE. STORE IN
PLASTIC-LINED FIBER DRUMS. AVOID STORAGE @ ELEVATED TEMP (>24C).
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF DUST IS >0.04MG/CUBIC METER, A NIOSH/MSHA
FUME HOOD/APPRVD RESP MUST BE USED. WEAR A NIOSH/MSHA APPRVD
FULLFACE, AIR SUPPLIED RESP/A FULLFACE RESP W/CARTRIDGE SUITABLE
FOR DUST CONC PRESENT. FOLLOW LOC REGS FOR RESP USE IN WORKPLACE.
Ventilation:USE A FUME HOOD WHEN WORKING W/DUST. LOC EXHAUST SHOULD BE
USED WHEN HNDLG THIS MATL IN BULK QTY.
Other Protective Equipment:WEAR PROT CLTHG W/LONG SLEEVES. IN
PRODUCTION AREAS, IT SHOULD BE LAUNDERED/DISCARDED AFTER EACH USE.
AN EYE (ING 8)
Work Hygienic Practices:IN PRODUCTION AREAS, A SHOWER AFTER EACH SHIFT
IS RECOM. AVOID EAT/DRINK IN AREAS WHERE MATL IS HNDLD.CLEAN UP
(ING 9)
Supplemental Safety and Health
U/I: 1000 TABS/BT 100 MG. FIRE FIGHT PROC: MATL. MOVE CONTRS FROM FIRE
AREA IF POSS W/OUT INCR PERSONAL RISK. DIKE AREA IF POSS TO CNTN
H*2O FOR LATER DISP. EFTS OF OVEREXP: INGEST: CAN BE HARMFUL, PO SS
FATAL IN LG AMTS. SYMP OF TOXICITY &CHRONIC EXPOS SAME AS IN INHAL.
REPROD EFTS: TERATOGENIC EFTS (BIRTH (ING 2)
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:383F,195C
pH:4-5.5
Evaporation Rate & Reference:NEGLIGIBLE
Solubility in Water:SOLUBLE
Appearance and Odor:WHITE, ODORLESS CRYSTALLINE POWDER THAT DARKENS ON
PROLONGED EXPOSURE TO LIGHT.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:DECOMPOSES @ TEMPS >194C.
Hazardous Decomposition Products:NONE KNOWN.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF WASTE ON SITE IN A CHEMICAL
INCINERATOR IF ALLOWED BY THE INCINERATOR PERMIT. IF NO ON-SITE
INCINERATOR IS AVAILABLE, DISPOSE OF WASTE IN A LICENSED CHEMICAL
INCINERATOR. DISPOSE OF I/A/W F EDERAL, STATE & LOCAL REGULATIONS .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PROVIDEX,SURGICAL SCRUB
Kit Part:Y
CAGE:00QD1
CAGE:00QD1
============= Composition/Information on Ingredients =============
Ingred Name:POVIDONE-IODINE
= Wt:7.5
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT) 3.5 ML/KG
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS: EYES, SKIN,
GASTROINTESTINAL TRACT. EFFECTS OF OVEREXPOSURE. ACUTE - SKIN:
ABSORPTION THROUGH SKIN CAUSES SEVERE HYPERNATREMIA AND ACIDOSIS
HAVE BEEN NOTED ALONG WITH INCREASED SERUM IO DINE LEVELS.
INGESTION: FATAL IN LARGE DOSES; LD50 3.5 ML/KG - RAT; INCREASED
SERUM IODINE LEVELS. - CHRONIC - UNKNOWN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION
======================= First Aid Measures =======================
First Aid:GET MEDICAL ATTENTION IF SYMPTOMS PERSIST. EYES: IMMEDIATELY
GENTLY FLUSH WITH PLENTY OF CLEANWATER. HOLD EYELIDS OPEN. SKIN:
REMOVE CONTAMINATED CLOTHING. WASH OFF AFFECTED AREA IMMEDIATELY
WITH PLENTY OF SOAPY WATER. CONTACT DOCTOR. INHALED: NOT
NECESSARY.INGESTION: OBTAIN MEDICAL ATTENTION PROMPTLY.
===================== Fire Fighting Measures =====================
Flash Point:NOT FLAMMABLE
Fire Fighting Procedures:WEAR APPROPRIATE BREATHING APPARATUS & EYE
PROTECTION. VAPOR MAY CAUSE EYE & SKIN IRRITATION.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR SKIN PROTECTIVE CLOTHING AND EYE SHIELD.
ABSORB SPILLS WITH INERT MATERIAL AND PLACE IN CONTAINER FOR
DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:NORMAL
Other Precautions:AS A GENERAL RULE, WHEN HANDLING PHARMACEUTICAL OR
LABORATORY PRODUCTS, AVOID ALL FORMS OF CONTACT AND INHALATION OF
DUST, FUMES, MISTS, AND/OR VAPORS ASSOCIATED WITH THE PRODUCT. WASH
THOROUGHLY AFTE R HANDLING AND BEFORE EATING OR DRINKING
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NORMAL.
Ventilation:GENERAL
Other Protective Equipment:EYE BATH, WASHING FACILITY, LAB COAT OR
UNIFORM.
Work Hygienic Practices:GOOD PRACTICE REQUIRES THAT GROSS AMOUNT OF ANY
CHEMICAL BE REMOVED FROM THE SKIN AS SOON AS PRACTICAL.
Supplemental Safety and Health
KEY1: N1. THIS IS PART OF FIRST AID KIT (NSN: 6545-00-116-1410). FOR
OTHER PARTS, SEE NSN 6505-01-121-2335 (BTCNF); NSN 6840-01-284-3982
(BGWGJ); AND NSN 6850-00-985-7166 (BHHYY).
================== Physical/Chemical Properties ==================
HCC:F3
Vapor Density:>AIR
VOC Grams/Liter:3.88
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:<1
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS AND UNSATURATED ORGANIC COMPOUNDS
Stability Condition to Avoid:EXCESSIVE HEAT
Hazardous Decomposition Products:IODINE VAPORS
Conditions to Avoid Polymerization:WILL NOT OCCUR
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF WASTE IN ACCORDANCE WITH LOCAL,
STATE, AND FEDERAL LAWS AND REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:AEROSHELL(R) FLUID 4 (MIL-H-5606A)
Resp. Party Other MSDS Num.:SHELL MSDS: 58100-07
CAGE:OO821
CAGE:OO821
CAGE:012A4
============= Composition/Information on Ingredients =============
Ingred Name:HYDROTREATED LIGHT NAPHTHENIC DISTILLATE (PETROLEUM)
CAS:64742-53-6
RTECS #:PY8036000
Minumum % Wt:80.
Maxumum % Wt:90.
Ingred Name:ADDITIVES
Minumum % Wt:10.
Maxumum % Wt:20.
===================== Hazards Identification =====================
LD50 LC50 Mixture:>5 G/KG RAT
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: MINIMALLY IRRITATING. SKIN:
MILDLY IRRITATING. PROLONGED AND REPEATED CONTACT MAY LEAD TO
VARIOUS SKIN DISORDERS SUCH AS DERMATITIS , OIL ACNE OR
FOLLICULITIS. RELEASE DURING HIGH USAGE MAY RESU LT IN INJECTION OF
OIL INTO THE SKIN CAUSING LOCAL NECROSIS. INHALATION: MILD
IRRITATION OF THE RESPIRATORY TRACT. INGESTION: MAY BE HARMFUL OR
FATAL IF SWALLOWED. MAY RESULT IN VOMITIMG. ASPIRATION ( BREATHING)
OF VOMITUS INTO THE LUNGS MUST BE AVOIDED AS EVEN SMALL AMOUNTS MAY
RESULT IN ASPIRATION NEUMONITIIS.
Effects of Overexposure:EYES: IRRITATION. SKIN: IRRITATION. PROLONGED
CONTACT MAY LEAD TO DERMATITIS, OIL ACNE, OR FOLLICULITIS, LOCAL
NECROSIS. LOCAL NECROSIS IS EVIDENCED BY DELAYED ONSET OF PAIN AND
TISSUE DAMAGE. INHAL ATION: IRRITATION OF UPPER RESPIRATORY TRACT.
INGESTION: VOMITING; ASPIRATION OF VOMITUS MAY RESULT IN ASPIRATION
PNEUMONITIS WHICH MAY BE EVIDENCED BY COUGHING, LABORED BREATHING
AND CYANOSIS (BLUISH SKIN)
Medical Cond Aggravated by Exposure:PREEXISTING SKIN AND RESPIRATORY
DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR 15 MINUTES WHILE HOLDING EYELIDS
OPEN. GET MEDICAL ATTENTION. SKIN: IF MATERIAL IS INJECTED UNDER
THE SKIN. GET MEDICAL ATTENTION PROMPTLY TO PREVENT SERIOUS INJURY.
INHALAT ION: REMOVE VICTIM TO FRESH AIR AND PROVIDE OXYGEN IF
BREATHING IS DIFFICULT. GET MEDICAL ATTENTION. INGESTION: DO NOT
INDUCE VOMITING. IF VOMITING OCCURS SPONTANEOUSLY, KEEP HEAD BELOW
HIPS TO PREVEN T ASPIRATION OF LIQUID INTO LUNGS. GET MEDICAL
ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:=107.2C, 225.F
Extinguishing Media:USE WATER FOG, FOAM, DRY CHEMICAL OR CO2. DO NOT
USE A DIRECT STREAM OF WATER. PRODUCT WILL FLOAT AND CAN BE
REIGNITED ON SURFACE OF WATER.
Fire Fighting Procedures:MATERIAL WILL NOT BURN UNLESS PREHEATED. DO
NOT ENTER CONFINED FIRE-SPACE WITHOUT FULL BUNKER GEAR (HELMET WITH
POSITIVE-PRESSURE NIOSH- APPROVED SELF-CONTAINED BREATHING
APPARATUS. COOL FIRE EXPOSED CONTAINERS WITH WATER.
Unusual Fire/Explosion Hazard:NONE IDENTIFIED
================== Accidental Release Measures ==================
Spill Release Procedures:MAY BURN BUT NOT READILY IGNITABLE. SMALL
SPILLS: TAKE UP WITH ABSORBENT. DISPOSE PROPERLY. LARGE: WEAR
RESPIRATOR & PROTECTIVE CLOTHING AS APPROPRIATE . SHUT OFF SOURCE
OF LEAK IF SAFE. DIKE & CONTA IN. REMOVE WITH VAC TRUCK OR PUMP TO
STORAGE SALVAGE VESSEL. SOAK UP RESIDUE WITH ABSORBENT SUCH AS
CLAY, SAND OR OTHER SUITABLE MAT'L. DISPOSE OF PROPERLY. FLUSH WITH
WATER TO REMOVE TRACE RESIDUE.
======================Handling and Storage ======================
Handling and Storage Precautions:IF EXPOSURE MAY OR DOES EXCEED
OCCUPATIONAL EXPOSURE LIMITS USE A NIOSH APPROVED RESPIRATOR TO
PREVENT OVEREXPOSURE. IAW CFR 1910.134 USE AN ATMOSPHERE SUPPLYING
RESPIRATOR OR AN AIR PURIFYING RESPIRA TOR FOR ORGANIC VAPORS AND
PARTICULATES.
TO AVOID EYE CONTACT. TEST DATA FROM PUBLISHED LITERATURE AND/OR
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF EXPOSURE MAY OR DOES EXCEED OCCUPATIONAL
EXPOSURE LIMITS (SECTION IV) USE A NIOSH-APPROVED RESPIRATOR TO
PREVENT OVEREXPOSURE. IN ACCORD WITH 29 CFR 1910.134 USE EITHER AN
ATMOSPHERE-SUPPLYING RESP IRATOR OR AN AIR-PURIFYING RESPIRATOR FOR
ORGANIC VAPORS AND PARTICULATES.
CLOTHING AS REQ TO MINIMIZE SKIN CONTACT. TEST DATA FROM PUBLISHED
Work Hygienic Practices:NONE IDENTIFIED
Supplemental Safety and Health
NOTE: IF MORE THAN 2.0 ML/KG IS INGESTED & VOMITING HAS NOT OCCURRED,
EMESIS SHOULD BE INDUCED WITH SUPERVISION. KEEP VICTIM HEAD BELOW
HIPS TO PREVENT ASPIRATION. IF SYMPTOMS SUCH AS LOSS OF GAG REFL
EX, CONVULSIONS OR UNCONSCIOUSNESS OCCUR BEFORE EMESIS, CONSIDER
GASTRIC LAVAGE USING A CUFFED ENDOTRACHEAL TUBE
================== Physical/Chemical Properties ==================
HCC:V6
Melt/Freeze Pt:=-59.4C, -75.F
M.P/F.P Text:(POUR POINT)
Vapor Pres:<0.1 (MMHG)
Spec Gravity:0.8692 (H20=1)
Viscosity:10 (CS @ 130F)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:RED LIQUID. SLIGHT HYDROCARBON ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIALS
Stability Condition to Avoid:AVOID HEAT, OPEN FLAMES
Hazardous Decomposition Products:CARBON MONOXIDE AND OTHER UNIDENTIFIED
ORGANIC COMPOUNDS MAY BE FORMED UPON COMBUSTION
=================== Toxicological Information===================
Toxicological Information:ACUTE DERMAL LD50 > 3.16 G/KG, RABBIT.
==================== Disposal Considerations ====================
Waste Disposal Methods:PLACE IN AN APPROPRIATE DISPOSAL FACILITY IN
COMPLIANCE WITH LOCAL REGULATIONS.
===================== Regulatory Information =====================
SARA Title III Information:BASED ON THE DATA AVAILABLE TO SHELL THIS
PRODUCT IS NOT REGULATED BY SARA, TITLE III.
Federal Regulatory Information:THE COMPONENTS OF THIS PRODUCT ARE
LISTED ON THE EPA/TSCA INVENTORY OF CHEMICAL SUBSTANCES. THIS
PRODUCT DOES NOT CONTAIN NOR WAS IT DIRECTLY MANUFACTURED WITH ANY
CLASS I OR CLASS II OZONE DEPLETING SUBSTANCES. IN ACCORDANCE WITH
SARA TITLE III, SECTION 313, THE ATTACHED ENVIRONMENTAL DATA SHEET
SHOULD ALWAYS BE COPIED AND SENT WITH THE MSDS.
State Regulatory Information:THE FOLLOWING CHEMICAL IS SPECIFICALLY
LISTED BY THE STATE OF MASSACHUSETTS ON THE STATE SUBSTANCE LIST:
HYDROTREATED LIGHT NAPHTHENIC DISTILLATE, CAS NUMBER 64742-53-6.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PR-1751
CAGE:DO551
CAGE:83574
CAGE:DO551
============= Composition/Information on Ingredients =============
Ingred Name:MANGANESE DIOXIDE (AS MANGANESE)
CAS:1313-13-9
RTECS #:OP0350000
Fraction by Wt: 5.0%
OSHA PEL:C,5 MG/M3/1 FUME TWA
ACGIH TLV:5 MG/M3 DUST/1 FUME
Ingred Name:CHLORODIPHENYL:42% CHLORINE (AROCHLOR 1242) (SARA III)
CAS:53469-21-9
RTECS #:TQ1356000
Fraction by Wt: 3.0%
OSHA PEL:S, 1 MG/M3
ACGIH TLV:S, 1MG/M3; 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:THIRAM (SARA III)
CAS:137-26-8
RTECS #:JO1400000
Fraction by Wt: <0.5%
OSHA PEL:5 MG/M3
ACGIH TLV:1 MG/M3; 9192
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
===================== Hazards Identification =====================
Effects of Overexposure:SKIN IRRITANT.
======================= First Aid Measures =======================
First Aid:SKIN:WASH THOROUGHLY W SOAP & WATER;EYES:WASH OUT IMMEDIATELY
W PLENTY OF WATER.GET MEDICAL ATTENTION;INHALATION:REMOVE AFFECTED
INDIVIDUAL TO FRESH AIR;INGESTION:IMMEDIATELY GET MEDICAL HELP.
===================== Fire Fighting Measures =====================
Flash Point:<73F PMCC
Lower Limits:1.0
Upper Limits:7.0
Extinguishing Media:FOAM,CO*2,DRY CHEM
Fire Fighting Procedures:NONE KNOWN
Unusual Fire/Explosion Hazard:CAN EMIT TOXIC VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:WIPE UP W RAGS/PAPER TOWELS.CLEAN SURFACE/AREA
W MEK USING APPROPRIATE PROTECTIVE EQUIPMENTS;LARGE SPILL:ELIMINATE
IGN SOURCES,STOP LEAK,& DIKE SPILL AREA.TRANSFER SPILL WASTE INTO
SALVAGE TANK FOR DI SPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP IN CLOSED CONTAINERS IN COOL/DRY
AREA.PROTECT CONTAINERS AGAINST PHYSICAL DAMAGE.
Other Precautions:AVOID REPEATED OR PROLONGED SKIN CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED IN ORDINARY CONDITIONS
Ventilation:ADEQUATE LOCAL EXHAUST TO MINIMIZE VAPORS.
Other Protective Equipment:PROTECTIVE HAND CREAM MAY BE USED.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F3
Spec Gravity:1.62
Solubility in Water:INSOLUBLE
Appearance and Odor:DARK GRAY PASTE,SLIGHT SULFIDE ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING & CORROSIVE MATERIALS
Stability Condition to Avoid:SOURCES OF IGNITION
Hazardous Decomposition Products:OXIDES OF SULFUR,HYDROGEN SULFIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT INCINERATE THE WASTE &
CONTAINERS(EMPTY/FULL) OF THE PRODUCT.DISPOSE OF WASTE IN TIGHTLY
CLOSED CONTAINERS IAW LOCAL,STATE & FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:STAIN,OIL,SEMI-TRANSPARENT,WOOD,DK REDWOOD
Preparer's Name:D. KIER
CAGE:0ALO9
CAGE:0ALO9
CAGE:0AL09
============= Composition/Information on Ingredients =============
Ingred Name:STODDARD SOLVENT
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 100%
Other REC Limits:NONE SPECIFIED
OSHA PEL:500 PPM
ACGIH TLV:100 PPM; 9293
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENTS
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: NASAL & RESPIRATORY
IRRITATION, DIZZINESS, WEAKNESS, FATIGUE, NAUSEA, HEADACHE,
POSSIBLE UNCONSCIOUSNESS, ASPHYXIATION. MAY BE HARMFUL OR FATAL.
SKIN: PROLONGED & REPEATED CONTACT W/SKIN C AN CAUSE DEFATTING &
DRYING OF SKIN RESULTING IN IRRITATION & DERMATITIS. EYE: SEVERE
IRRITATION, REDNESS, TEARING *
Effects of Overexposure:* & BLURRED VISION. INGESTION: CAN CAUSE
GASTROINTESTINAL IRRITATION, NAUSEA, VOMITING & DIARRHEA.
ASPIRATION OF MATERIAL INTO LUNGS CAN CAUSE CHEMICAL PNEUMONITIS
WHICH CAN BE FATAL. REPORTS HAVE ASS OCIATED REPEATED & PROLONGED
OCCUPATIONAL OVEREXPOSURE TO SOLVENT W/PERMANENT BRAIN & NERVOUS
SYSTEM DAMAGE.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE VICTIM FROM FURTHER EXPOSURE & RESTORE
BREATHING IF REQUIRED. EYE: FLUSH W/WATER FOR AT LEAST 15 MINUTES
WHILD HOLDING EYELIDS OPEN. SKIN: WASH CONTAMINATED SKIN W/MILD
SOAP & WATER . INGESTION: DO NOT INDUCE VOMITING. OBTAIN MEDICAL
ATTENTION IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:112F,44C
Lower Limits:0.8
Upper Limits:5.0
Extinguishing Media:DRY CHEMICAL, CO2, FOAM AND WATER FOG.
Fire Fighting Procedures:DO NOT ENTER CONFINED FIRE SPACE W/O ADEQUATE
PROTECT CLOTH & APPROVED POSITIVE PRESS SCBA. EXCLUDE AIR. USE
WATER ONLY AS FOG. COOL FIRE EXPOSED CNTNR W/WATER.
Unusual Fire/Explosion Hazard:AVOID EXCESSIVE HEAT, OPEN FLAMES & ALL
IGNITION SOURCES.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE IGNITION SOURCES. VENT AREA. ABSORB
SPILL W/ABSORB MAT'L & PLACE IN CLOSED CNTNR. LARGE SPILL-DIKE AREA
TO PREVENT MAT'L FROM ENTERING WATER SYSTEMS. WEAR PROTECT
EQUIPMENT DURING CLEANUP. NOTI FY PROPER AUTHORITIES IF SPILL
EXCEEDS 220 LBS.
======================Handling and Storage ======================
Handling and Storage Precautions:COMBUSTIBLE LIQUID. STORE IN A COOL,
DRY, WELL-VENTILATED AREA, AWAY FROM HEAT & IGNITION SOURCES. AVOID
PROLONGED OR REPEATED CONTACT W/SKIN.
Other Precautions:AVOID BREATHING SPRAY/MIST. LAUNDER CONTAM CLOTHING
PRIOR TO REUSE. GROUND CONTAINERS WHEN POURING. LIMIT FREE FALL TO
MINIMIZE STATIC CHARGE BUILD-UP. EMPTY CONTAINERS MAY BE HZDS FROM
PRODUCT RESIDU E & VAPORS & ALL CAUTIONS APPLY TO THEM.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:A CANISTER-TYPE RESPIRATOR MUST BE WORN TO
PREVENT THE INHALATION OF VAPORS OR SPRAY MISTS WHEN THE TLV/PEL IS
EXCEEDED.
Ventilation:GENERAL VENT IS REQUIRED DURING NORMAL USE. LOCAL VENT MAY
BE REQUIRED IN CERTAIN CASES TO KEEP EXPOS LEVEL BELOW LIMIT.
Other Protective Equipment:WEAR PROTECTIVE CLOTHING TO PREVENT SKIN
CONTACT. EYE WASH STATION/SAFETY SHOWER SHOULD BE AVAILABLE.
Work Hygienic Practices:USE GOOD PERSONAL HYGIENE.
Supplemental Safety and Health
DO NOT TAKE INTERNALLY. CLOSE CONTAINER AFTER EACH USE. KEEP AWAY FROM
CHILDREN.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:301 TO 402F
Vapor Pres:>7.0 @ 38C
Vapor Density:4.8
Spec Gravity:0.94
Viscosity:10"-25"
Evaporation Rate & Reference:SLOWER THAN BUTYL ACETATE
Solubility in Water:NEGLIGIBLE
Appearance and Odor:THIN LIQUID, MILD ODOR.
Percent Volatiles by Volume:27-29
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS, LEWIS OR MINERAL ACIDS.
Hazardous Decomposition Products:CARBON MONOXIDE AND CARBON DIOXIDE ARE
PRODUCED ON COMBUSTION.
Conditions to Avoid Polymerization:AVOID EXCESSIVE HEAT, OPEN FLAME AND
ALL IGNITION SOURCES.
==================== Disposal Considerations ====================
Waste Disposal Methods:TREAT AS HAZARDOUS WASTE IF NOT POSSIBLE TO
RECLAIM. DISPOSE OF AT A LICENSED WASTE DISPOSAL COMPANY OR
INCINERATE W/APPROVAL OF ENVIRONMENTAL AUTHORITY. ALL DISPOSAL
PROCEDURES MUST COMPLY W/LOCAL, S TATE AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:2824, DISPERSALLOY DISPERSED PHASE ALLOY (SUPP DATA)
CAGE:11107
CAGE:11107
============= Composition/Information on Ingredients =============
Ingred Name:SILVER (SARA III)
CAS:7440-22-4
RTECS #:VW3500000
OSHA PEL:0.01 MG/M3
ACGIH TLV:0.1 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:TIN
CAS:7440-31-5
RTECS #:XP7320000
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3
Ingred Name:COPPER (SARA III)
CAS:7440-50-8
RTECS #:GL5325000
OSHA PEL:0.1MG/M3 FUME/1 DUST
ACGIH TLV:0.2MG/M3 FUME
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ZINC (SARA III)
CAS:7440-66-6
RTECS #:ZG8600000
OSHA PEL:10 MG/M3 (ZNO)
ACGIH TLV:10 MG/M3 (ZNO)
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(ORAL,RAT) >5000 MG/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE AND CHRONIC: EYES: MAY CAUSE
IRRITATION UPON CONTACT. SKIN: AVOID REPEATED CONTACT WITH SKIN,
CHRONIC EXPOSURE MAY CAUSE ARGYRIA (GRAYISH-BLUE PIGMENTATION OF
THE SKIN). NO KNOWN SERIOUS TOXIC S YMPTOMS HAVE BEEN NOTED
FOLLOWING EXPOSURE. INHAL: (POWDER ONLY) INHAL OF ALLOY POWDER MAY
CAUSE IRRIT (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: OF MUCOUS MEMBRANES. INGEST:
INGESTION OF ALLOY MAY CAUSE GI TRACT IRRITATION, NAUSEA OR
DIARRHEA.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: IMMEDIATELY FLUSH EYES WITH COPIOUS QTYS OF WATER FOR
AT LEAST 15 MIN. SEEK MED ATTN IF IRRITATION OR DISCOMFORT
PERSISTS. SKIN: WASH THOROUGHLY WITH SOAP AND WATER. INHAL: GENTLY
BLOW NOSE AND IRRIGATE WITH CLEAN WATER. CONSULT PHYSICIAN IF
IRRITATION PERSISTS. INGEST: IF SWALLOWED, SEEK MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Extinguishing Media:EXTINGUISHING MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
================== Accidental Release Measures ==================
Spill Release Procedures:PROVIDE EXHAUST VENTILATION WHEN POSSIBLE.
CAREFULLY SWEEP OR VACUUM INTO ACCEPTABLE WASTE CONTAINER. AVOID
GENERATING AIRBORNE DUST.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY ENVIRONMENT.
AVOID CONTACT OR GENERATION OF DUST.
Other Precautions:NONE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED. NIOSH/MSHA APPROVED RESPIRATOR
APPROPRIATE FOR EXPOSURE OF CONCERN .
Other Protective Equipment:NONE
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
MFR TRADE NAME/PART NO: TABLETS, POWDER AND CAPSULES.
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:>1832F,>100
Spec Gravity:8.0
Appearance and Odor:A METALLIC GRAYISH TABLET OR FREE FLOWING, METALLIC
GRAY POWDER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACETYLENE, HYDROGEN PEROXIDE, OR ETHYLENEIMINE.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:THE PRODUCT OR INDIVIDUAL COMPONENTS MAY BE
SALAVAGED OR RECLAIMED FOR REUSE. WASTE MATERIAL MAY BE DISPOSED OF
ACCORDING TO LOCAL, STATE AND FEDERAL REGULATIONS .
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:W1105 SHOCK RESISTANT
CAGE:0U0J3
CAGE:0U0J3
============= Composition/Information on Ingredients =============
Ingred Name:NON-HAZARDOUS FOR INGREDIENTS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN: IRRITATION.
Explanation of Carcinogenicity:NONE
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR 15 MINUTES. SKIN: WASH THOROUGHLY
W/SOAP & WATER. INGESTION: CALL PHYSICIAN IMMEDIATELY. OBTAIN
MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:338F
Extinguishing Media:DRY CHEMICAL, FOAM, CO2, WATERFOG, SAND/EARTH
Fire Fighting Procedures:FIRE FIGHTERS SHOULD WEAR AN APPROVED SELF
CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:DENSE SMOKE
================== Accidental Release Measures ==================
Spill Release Procedures:TRANSFER BULK OF MATERIAL INTO ANOTHER
CONTAINER. ABSORB REMAING RESIDUE W/PROPER ABSORBENTS SUCH AS SAND,
EARTH, VERMICULITE.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED.
============= Exposure Controls/Personal Protection =============
Other Protective Equipment:FULL FACE SHIELD
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Spec Gravity:0.951
Solubility in Water:NEGLIGIBLE
Appearance and Odor:AMBER SEMI SOLID GREASE, W/MINERAL OIL ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, HYDROGEN PEROXIDE, CHROMIC ACID, BROMINE
Hazardous Decomposition Products:CO, CO2
==================== Disposal Considerations ====================
Waste Disposal Methods:SWEEP UP & DISPOSE OF IN ACCORDANCE W/FEDERAL,
STAE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:G-382B RAPIDOPRINT STABILIZER
CAGE:NO094
CAGE:NO094
CAGE:59735
============= Composition/Information on Ingredients =============
Ingred Name:HYDROXYETHYLENEDIAMINETRIACETATE
CAS:139-89-9
Fraction by Wt: <1%
Ingred Name:SODIUM SULFITE
CAS:7757-83-7
RTECS #:WE2150000
Fraction by Wt: 10-15%
Ingred Name:AMMONIUM THIOCYANATE (SARA III)
CAS:1762-95-4
RTECS #:XK7875000
Fraction by Wt: 15-20%
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ACETIC ACID (SARA III)
CAS:64-19-7
RTECS #:AF1225000
Fraction by Wt: 1-5%
OSHA PEL:10 PPM
ACGIH TLV:10 PPM/15 STEL; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Effects of Overexposure:EYE & SKIN-IRRITATION. INGEST-IRRIT OF MUCOUS
MEMBRANES OR DIGESTIVE TRACT; SLIGHTLY TO MODERATELY TOXIC.
======================= First Aid Measures =======================
First Aid:EYES-FLUSH W/WATER 15 MIN;GET MED ATTN. SKIN-REMOVE CONTAM
CLOTH;FLUSH AFFECTED AREAS W/WATER 15 MIN. INHAL-GET TO FRESH AIR.
INGEST-GET IMMED MED ATTN.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:AS SUITABLE FOR SURROUNDING FIRE.
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH SPILL W/LGE QTY WATER (AT LEAST 20 TO 1
DILUTION) IF ACCEPT TO LOCAL SEWER AUTHORITY. OTHERWISE,APPLY
SUITABLE ABSORBENT & COLLECT INTO IMPERVIOUS CONTAINER.
======================Handling and Storage ======================
Handling and Storage Precautions:NO SPECIAL RQMTS. WORKERS SHOULD
ALWAYS WEAR THEIR SPECIAL PROTECT EQUIP.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQD
Ventilation:GOOD LOCAL EXHAUST
Other Protective Equipment:APRON
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:212F/100C
Spec Gravity:1.147
pH:6.00
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR,COLORLESS LIQUID
Percent Volatiles by Volume:NONE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CONTACT W/STRONG ACIDS & HEAT EMIT HIGHLY TOXIC FUMES OF SULFUR DIOXIDE
& CYANIDES.
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:THROUGH A LICENSED CHEM WASTE DISPOSAL SERVICE
SUBJECT TO FED,STATE & LOCAL REGS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:FP-93A(M) PENETRANT (SEE SUPPL DATA)
Kit Part:Y
CAGE:98733
CAGE:98733
============= Composition/Information on Ingredients =============
Ingred Name:DISTILLATE (PETROLEUM),HYDROTREATED MIDDLE; NOTE: ON MSDS,
MFR SIMPLY STATED AS "PETROLEUM HYDROCARBON" FOR ABOVE CAS #.
CAS:64742-46-7
RTECS #:JN9379645
OSHA PEL:5 MG/CUM
ACGIH TLV:5 MG/CUM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE SLIGHT SKIN IRRITATION;
VAPORS OR OIL MIST MAY CAUSE MILD IRRITATION OF UPPER RESPIRATORY
TRACT.
Effects of Overexposure:EYES:MAY CAUSE IRRITATION; SKIN:SLIGHT
IRRITATION ON CONTACT WITH LIQUID; INHALATION:VAPORS OR MIST OF
PRODUCT MAY CAUSE MILD IRRITATION OF UPPER RESPIRATORY TRACT.
INGESTION:MAY RESULT IN VOMITING. A SPIRATION MUST BE AVOIDED.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN AND RESPIRATORY
DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH WITH WATER FOR AT LEAST 15 MINUTES.GET MEDICAL
HELP IR IRRITATION OCCURS OR PERSISTS; SKIN:FLUSH WITH WATER.WASH
WITH LUKE WARM WATER & SOAP.GET MEDICAL HELP FOR PERSISTING
IRRITATION; INHA LATION:REMOVE TO FRESH AIR.PROVIDE OXYGEN IF
BREATHING IS DIFFICULT.GET MEDICAL ASSISTANCE IF NEEDED;
INGESTION:IF SWALLOWED, DO NOT INDUCE VOMITING.GET MEDICAL
ATTENTION.NOTHING BY MOUTH TO UNCONSC.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:210F/98.9C
Extinguishing Media:WATER FOG,DRY CHEMICAL,CARBON DIOXIDE OR FOAM; DO
NOT USE DIRECT STREAM OF WATER ON THE FIRE.
Fire Fighting Procedures:IN CONFINED AREA,DO NOT ENTER WITHOUT A FULL
BUNKER GEAR INCLUDING A POSITIVE PRESSURE NIOSH APPROVED
SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:CONTAINERS MAY BURST AND/OR RUPTURE IN
INTENSE HEAT OF FIRE. PER MANUFACTURER,PREHEATED PRODUCT MAY IGNITE
IN AIR WHEN EXPOSED TO FLAME.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE IGNITION SOURCES.WEAR APPROPRIATE
PROTECTIVE CLOTHING AND RESPIRATORS.SOAK UP WITH ABSORBENT.PLACE
WASTE IN SEALED CONTAINERS.FLUSH WITH WATER.LG LIQ:DIKE LIQUID &
PUMP INTO SALVAGE TANK.ABS ORB RESIDUE WITH COMM ABSORBENT & PUT IN
CLOSED DR
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM SOURCES OF
HEAT/IGNITION.STORE IN COOL,DRY & VENTILATED AREA.DO NOT STORE NEAR
OXIDIZING MATERIAL;AVOID PHYSICAL DAMAGE TO CONTAINERS.
Other Precautions:MINIMIZE SKIN CONTACT.AVOID BREATHING VAPORS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NEEDED IN NORMAL CONDITIONS OR USES WHEN
VAPORS/MIST CONCENTRATIONS ARE BELOW TLV/PEL LIMITS. WEAR NIOSH
APPROVED ORGANIC TYPE RESPIRATOR IN ABSENCE OF PROPER ENVIRONMENTAL
CONTROL.
Ventilation:LOCAL EXHAUST OR MECHANICAL(GENERAL) TO MAINTAIN TLV OR
BELOW TLV LIMITS.
Other Protective Equipment:CHEMICAL RESISTANT APRON TO PREVENT
CLOTHING/SKIN CONTACT.
Work Hygienic Practices:WASH HANDS WITH SOAP & WATER BEFORE EATING,
SMOKING OR USING TOILET FACILITIES;DO NOT EAT/DRINK IN VAPOR
CONTMNTD AREA.
Supplemental Safety and Health
NSN FOR A KIT OF 2 PARTS UNDER TYPE I,METHOD 1,LEVEL 2 OF
MIL-I-25135,REV D;PER QPL-25135-15,THE SET MAY CONSIST OF FP-93A(M)
PENETRANT AND E-58A OR E-58D EMULSIFIER (I.E. THE MFR MAY SUPPLY
EITHER E- 58A OR E-58D EMULSIFIER WITH FP-93A(M) PENETRANT UNDER
THIS NSN);KEY1:N1;THIS DATA ENTRY DESCRIBES: FP-93A(M) PENETRANT.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:380F(193.3C
Spec Gravity:ABOUT 1.2
Solubility in Water:INCOMPLETE
Appearance and Odor:YELLOW-GREEN LIQUID. SLIGHT HYDROCARBON ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIAL
Stability Condition to Avoid:SOURCE OF HEAT/IGNITION. AVOID EXPOSURE TO
OXIDIZING MATERIALS.
Hazardous Decomposition Products:OXIDES OF CARBON (CARBON
MONOXIDE,CARBON DIOXIDE) AND OTHER UNIDENTIFIED ORGANIC PRODUCTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:PER MANUFACTURER, THE WASTE CAN BE INCINERATED
OR DISPOSED OF AS EPA HAZARDOUS WASTE # D001,IGNITABLE WASTE, IN
FULL COMPLIANCE WITH ALL FEDERAL STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:03W040 POLYURETHANE
Kit Part:Y
Preparer's Name:N. GAUL
CAGE:33461
CAGE:33461
============= Composition/Information on Ingredients =============
Ingred Name:2-ETHOXYETHYL ACETATE (CELLOSOLVE ACETATE) (EGEEA)
CAS:111-15-9
RTECS #:KK8225000
Fraction by Wt: 25%
OSHA PEL:S,100 PPM
ACGIH TLV:S, 5 PPM; 9192
Ingred Name:N-BUTYL ACETATE (SARA III)
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: <1%
OSHA PEL:150 PPM/200 STEL
ACGIH TLV:150 PPM/200STEL;9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TOLUENE (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: <1%
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 5%
OSHA PEL:200 PPM/300 STEL
ACGIH TLV:200 PPM/300STEL 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ETHYL ACETATE (SARA III)
CAS:141-78-6
RTECS #:AH5425000
Fraction by Wt: <5%
OSHA PEL:400 PPM
ACGIH TLV:400 PPM; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:PROPYLENE GLYCOL METHYL ETHER ACETATE
CAS:108-65-6
RTECS #:AI8295000
Fraction by Wt: <0.1%
Ingred Name:DIBUTYLTIN DILAURATE
CAS:77-58-7
RTECS #:WH7000000
Fraction by Wt: <0.1%
OSHA PEL:0.1 MG SN/M3 SKIN
ACGIH TLV:0.1 MG SN/M3
Ingred Name:"NOT HAZARDOUS" REMAINDER OF INGREDIENTS NOT NAMED AND THUS
RATED BY MFR AS NOT HAZARDOUS.
Fraction by Wt: >62%
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL RAT LD50 IS NOT KNOWN
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:PRODUCT IS IRRITATING TO BODY
TISSUES. MAY CAUSE DROWSINESS AND IRRITATE NOSE & THROAT. LARGE
AMOUNTS CAN CAUSE SERIOUS INJURY. CHRONIC: REPEATED & PROLONGED
SKIN CONTACT CAUSES SERIOUS IRRITATI ON & BURNS. VAPORS MAY INJURE
LUNGS, LIVER, KIDNEY & CENTRAL NERVOUS SYSTEM.
Explanation of Carcinogenicity:THE PRODUCT CONTAINS NO INGREDIENT THAT
IS LISTED BY IARC, NTP OR OSHA AS A CARCINOGEN.
Effects of Overexposure:OVEREXPOSURE MAY LEAD TO EYE, SKIN &
RESPIRATORY TRACT IRRITATION. VAPORS MAY CAUSE DIZZINESS,
HEADACHES, NAUSEA, AND SKIN/EYE IRRITATION. INHALING LIQUID WHILE
VOMITING CAN SERIOUSLY INJURE LUNGS. MA Y BURN OR BE ABSORBED
THROUGH SKIN DURING PROLONGED OR REPEATED CONTACT, CAUSING SERIOUS
INTERNAL INJURY.
Medical Cond Aggravated by Exposure:PERSONS WITH EXISTING EYE, SKIN,
AND RESPIRATORY DISORDERS MAY BE AT INCREASED RISK WHEN HANDLING OR
USING THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH W/WATER 15 MIN, HOLD LIDS OPEN. SKIN:WASH WITH
SOAP & WATER. REMOVE CONTAMINATED CLOTHING AND LAUNDER BEFORE
REUSE. INHALED:REMOVE TO FRESH AIR. RESTORE BREATHING IF
NECESSARY.INGESTED:D O NOT INDUCE VOMITING. GIVE 2 LARGE GLASSES
OF MILK OR WATER AND GET IMMEDIATE MEDICAL CARE. GIVE NOTHING BY
MOUTH IF UNCONSCIOUS. IF IRRITATION PERSISTS OR IS SEVERE,SEE A
DOCTOR.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:23.0F,-5.0C
Lower Limits:1.2
Extinguishing Media:USE CARBON DIOXIDE, FOAM, DRY CHEMICAL, OR WATER
FOG.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY CAUSE
PRODUCTION OF HAZARDOUS DECOMPOSITION PRODUCTS.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE SOURCES OF IGNITION. USE ABSORBENT
MATERIAL TO COLLECT AND CONTAIN FOR SALVAGE OR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED AND AWAY FROM
HEAT, SPARKS, AND OPEN FLAME. FLAMMABLE LIQUID; EMPTY CONTAINERS
MAY CONTAIN HAZARDOUS VAPORS AND RESIDUES.
Other Precautions:STATIC ELECTRICITY MAY ACCUMULATE AND CREATE A FIRE
HAZARD. GROUND FIXED EQUIPMENT. USE AT ELEVATED TEMPERATURES OR
SPRAY APPLICATIONS MAY REQUIRE ADDED PRECAUTIONS FOR PERSONAL
PROTECTION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESPIRATOR WILL NOT NORMALLY BE NECESSARY. USE
NIOSH/MSHA APPROVED AIR SUPPLIED RESPIRATOR OR RESPIRATOR FOR
ORGANIC DUST/VAPOR IF EXPOSURE IS ABOVE THE TLV/PEL. SEE 29 CFR
1910.134 FOR REGULATIONS P ERTAINING TO RESPIRATOR USE.
Ventilation:LOCAL AND MECHANICAL(GENERAL) ARE BOTH RECOMMENDED. AVOID
OPEN ELECTRICAL IGNITION SOURCES NEAR PRODUCT VAPOR AREAS.
Other Protective Equipment:EYE WASH STATION & SAFETY SHOWER. WEAR
INDUSTRIAL TYPE WORK CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:USE GOOD CHEMICAL HYGIENE PRACTICE. AVOID
UNNECESSARY CONTACT.
Supplemental Safety and Health
DO NOT HANDLE UNTIL MANUFACTURER'S SAFETY PRECAUTIONS HAVE BEEN READ
AND UNDERSTOOD.
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:B.P. Text:169F,76C
Vapor Density:>1
Evaporation Rate & Reference:1.24 (BUTYL ACETATE = 1)
Appearance and Odor:WHITE LIQUID, SOLVENT ODOR
Percent Volatiles by Volume:45.8
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH TEMPERATURES, SPARKS, AND OPEN FLAMES
Hazardous Decomposition Products:CARBON DIOXIDE AND OTHER TRACES OF
INCOMPLETELY BURNED CARBON PRODUCTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE I/A/W ALL FEDERAL, STATE AND LOCAL
REGULATIONS. DGSC-HMIS SUGGESTS THAT DISPOSAL MAY BE DONE BY
INCINERATION.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:SPEED SATIN LATEX WALL PAINT, 3418
CAGE:72818
CAGE:72818
CAGE:01PD6
============= Composition/Information on Ingredients =============
Ingred Name:CALCIUM CARBONATE; (LIMESTONE)
CAS:1317-65-3
RTECS #:EV9580000
Fraction by Wt: 1-5%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:KAOLIN; (CERAMIC MATERIALS AND WARES, CHEMICALS)
CAS:66402-68-4
Fraction by Wt: 10-20%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:TALC (POWDER), CONTAINING NO ASBESTOS FIBERS; (TALC)
CAS:14807-96-6
RTECS #:WW2710000
Fraction by Wt: 10-20%
OSHA PEL:20 MPPCF
ACGIH TLV:2 MG/M3 RDUST
Ingred Name:PROPIONIC ACID, 2-METHYL-, MONOESTER WITH
2,2,4-TRIMETHYL-1,3-PENTANEDIOL
CAS:25265-77-4
RTECS #:UF6000000
Fraction by Wt: 1-5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SILICA, CRYSTALLINE - QUARTZ; (QUARTZ)
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 1-10%
OSHA PEL:N/K
ACGIH TLV:0.1 MG/M3 RDUST
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 5-10%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:VINYL ACETATE/ACRYLIC POLYMER; (2-PROPENOIC ACID, BUTYL
ESTER, POLYMER WITH ETHENYL ACETATE)
CAS:25067-01-0
Fraction by Wt: 5-10%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 5-10%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 30-40%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:VOLATILE ORGANIC COMPOUND: 104.29 G/L
RTECS #:9999999VO
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:EXPLAN OF CARCIN: CARCINOGENS, 1994: ANTICIPATED TO BE
CARCINOGEN.
RTECS #:9999999ZZ
Ingred Name:EFTS OF OVEREXP:OF CARCIN WAS SHOWN IN MALE & FEMALE MICE
EXPOS UNDER SAME CNDTNS. MICROSCOPIC EXAM OF LUNGS OF (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12: RATS & MICE EXPOS TO TALC REVEALED ADDNL EXPOS
RELATED EFTS PRIMARILY ASSOC W/INFLAMMATORY RESPONSE. (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13: CRYSTALLINE SILICA IS A KNOWN CAUSE OF SILICOSIS, A
NONCANCEROUS LUNG DISEASE.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC: W/LG AMTS OF WATER, ESPECIALLY UNDER LIDS
FOR AT LST 15 MIN. IF IRRIT OR OTHER EFTS PERSIST, (ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15: OBTAIN MED TREATMENT. INGEST: IF SWALLOWED, OBTAIN
MED TREATMENT IMMED.
RTECS #:9999999ZZ
Ingred Name:SPILL PROC: SHUT OFF LEAK IF SAFE TO DO SO. DIKE & CONTAIN
SPILL. PUMP TO STORAGE OR SALVAGE VESSELS. USE ABSORB(ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17:TO PICK UP EXCESS RESIDUE. KEEP SALVAGEABLE MATL &
RINSE WATER OUT OF SEWERS & WATERCOURSES. SM SPILLS- (ING 19)
RTECS #:9999999ZZ
Ingred Name:ING 18: USE ABSORBENT TO PICK UP RESIDUE & DISPOSE OF
PROPERLY.
RTECS #:9999999ZZ
Ingred Name:OTHER PRECS: AVOID CNDTNS WHICH RSLT IN FORMATION OF
INHALABLE PARTICLES SUCH AS SPRAYING/ABRADING (SANDING) (ING 21)
RTECS #:9999999ZZ
Ingred Name:ING 20: PAINTED SURFS. IF SUCH CNDTNS CANNOT BE AVOIDED,
USE APPROP NIOSH APPRVD RESP PROT. EMPTY CNTNRS MAY (ING 22)
RTECS #:9999999ZZ
Ingred Name:ING 21: CONTAIN HAZ RESIDUES. GROUND EQUIP WHEN
TRANSFERRING TO PREVENT ACCUMULATION OF STATIC CHARGE.
RTECS #:9999999ZZ
Ingred Name:EYE PROT: & FULL LENGTH FACESHIELD .
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHAL: IRRIT OF RESP TRACT, LUNGS.
PRLNGD INHAL MAY LEAD TO DROW, DIZZ &/OR LT HEAD, UNCOORD, COUGH,
SNEEZING, RESP PROBS, ANESTH EFT OR NARCOS, LOSS OF CONSCIOUSNESS.
SKIN: IRRIT. PRLNGD/RPTD CNTCT C AN CAUSE TEARING, REDNESS, SEV
IRRIT, CORNEAL INJURY. INGEST: MAY CAUSE DROW, DIZZ &/OR LT HEAD,
HDCH, (EFTS OF OVEREXP)
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-QUARTZ: IARC
MONOGRAPHS, SUPP, VOL 7, PG 341, 1987:GROUP 2A. NTP 7TH ANNUAL
REPORT ON (ING 11)
Effects of Overexposure:HLTH HAZ: NAUS, VOMIT, DIARR, GI DISTURBS, CNS
DEPRESS, ANESTH EFT OR NARCOS, KIDNEY DMG, LOSS OF CONSCIOUSNESS.
INHAL OF NON-ASBESTIFORM COSMETIC GRADE TALC FOR 2 YRS AT 6 &
18MG/M3 PRDCED CLEAR EVID OF CARCIN IN FEMALE RATS (LUNG & ADRENAL
TUMORS) & SOME EVID OF CARCIN IN MALE RATS (ADRENAL TUMORS). NO
EVID (ING 12)
Medical Cond Aggravated by Exposure:EYE, SKIN, RESPIRATORY DISORDERS.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. RESTORE & SUPPORT CONTINUED BRTHG.
GET EMER MED ATTN. HAVE TRAINED PERS GIVE OXYGEN IF NEC. GET MED
HELP FOR ANY BRTHG DFCLTY. REMOVE TO FRESH AIR IF INHAL CAUSES EYE
WATERI NG, HDCHS, DIZZ/OTHER DISCOMFORT. SKIN:FLUSH FROM SKIN
W/WATER. THEN WASH THOROUGHLY W/SOAP & WATER. REMOVE CONTAMD CLTHG;
WASH BEFORE REUSE. IF IRRIT OCCURS, CONSULT MD. EYES: FLUSH IMMED
(ING 15)
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:DRY CHEMICAL OR FOAM WATER FOG. CARBON DIOXIDE.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . WATER MAY BE USED TO COOL AND PROTECT EXPOSED
CONTAINERS.
Unusual Fire/Explosion Hazard:CLSD CNTNRS MAY EXPLODE WHEN EXPOS TO
EXTREME HEAT/FIRE. VAPS ARE HVR/AIR & MAY TRAVEL LONG DISTS TO
IGNIT SOURCE & FLASH BACK. VAPS CAN FORM EXPLO MIXS(SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:COMPLY W/ALL APPLIC HLTH & ENVIRONMENTAL REGS.
ELIM ALL SOURCES OF IGNIT. VENT AREA. EVACUATE ALL UNNEC PERS.
PLACE COLLECTED MATL IN PROPER CNTNR. VACUUM CLEAN SPILLAGE.
COMPLETE PERSONAL PROT EQUIP MUST BE USED DURING CLEANUP. LG
SPILLS - (ING 17)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE BELOW 100F. KEEP AWAY FROM HEAT,
SPARKS AND OPEN FLAME. KEEP FROM FREEZING.
Other Precautions:USE ONLY W/ADEQ VENT. DO NOT TAKE INTERNALLY. KEEP
OUT OF REACH OF CHILDREN. AVOID CNTCT W/SKIN & EYES & BRTHG OF
VAPS. WASH HANDS THOROUGHLY AFTER HNDLG, ESP BEFORE EATING/SMKNG.
KEEP CNTNRS TIGHTLY CLSD & UPRIGHT WHEN NOT IN USE. (ING 20)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:CONTROL ENVIRONMENTAL CONCENTRATIONS BELOW
APPLICABLE STANDARDS. WHERE RESPIRATORY PROTECTION IS REQUIRED, USE
ONLY NIOSH APPROVED RESPIRATORS IN ACCORDANCE WITH OSHA STANDARD 29
CFR 1910.134.
Ventilation:PROVIDE DILUTION VENTILATION OR LOCAL EXHAUST TO PREVENT
BUILDUP OF VAPORS.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
IMPERVIOUS CLOTHING, APRON.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EXPLO HAZ:IN AIR AT ELEVATED TEMPS. CLSD CNTNRS MAY BURST IF EXPOS TO
EXTREME HEAT/FIRE. IN CLSD TANKS, WATER/FOAM MAY CAUSE
FROTHING/ERUPTION. CNDTNS TO AVOID: NEAR ACIDS, FREEZING, SPKS,
OPEN FLAME. MATL TO AVOID: HYDROGEN FLUORIDE, MAGNESIUM, CAUSTICS,
MINERAL ACIDS, SODIUM, POTASSIUM.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>212F,>100C
Spec Gravity:1.36
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:67.64
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS, ACIDS, REDUCING AGENTS, BASES, ALUMINUM, ZINC, METALS,
PEROXIDES, NITRIC ACID, HYDROFLUORIC ACID, (SUPDAT)
Stability Condition to Avoid:ELEVATED TEMPS, CNTCT W/OXIDIZING AGENT,
CNTCT W/ALUMINUM OR ZINC, ULTRAVIOLET LIGHT, HIGH CONC OF DUST,
STOR (SUPDAT)
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE, ACRID
FUMES, OXYGEN, ALDEHYDES, TOXIC GASES, ACIDS. PROPIONALDEHYDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE AND LOCAL REGULATIONS. AVOID DISCHARGE TO NATURAL
WATERS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:A38P500 ACETIC ACID, GLACIAL
CAGE:1B464
CAGE:1B464
============= Composition/Information on Ingredients =============
Ingred Name:ACETIC ACID (GLACIAL)
CAS:64-19-7
RTECS #:AF1225000
Fraction by Wt: 97%
OSHA PEL:25 MG/CUM
ACGIH TLV:25 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(RAT): 3310 MG/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: SEVERE IRRITATION & BURNS
W/POSSIBLE IRREVERSIBLE DAMAGE. SKIN: SEVERE IRRITATION,
SENSITIZATION, AN ALLERGIC REACTION, DERMATITIS. INGESTION: SEVERE
& PERMANENT DAMAGE TO DIGESTIVE TRACT. INHA LATION: EFFECTS MAY BE
DELAYED. CAUSES RESPIRATORY TRACT IRRITATION. MAY CAUSE CHRONIC
BRONCHITIS & EROSION OF TEETH.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, PAIN, NAUSEA, VOMITING, DIARRHEA,
SHOCK
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/PLENTY OF WATER FOR 15 MINS. SKIN: IMMEDIATELY
FLUSH W/PLENTY OF SOAP & WATER FOR 15 MINS. INGESTION: DON'T INDUCE
VOMITING. IF CONSCIOUS & ALERT, GIVE 2-4 CUPFULS OF MILK/WATER.
NEVER G IVE ANYTHING BY MOUTH IF UNCONSCIOUS. INHALATION: REMOVE TO
FRESH AIR IMMEDIATELY. GIVE CPR/OXYGEN IF NECESSARY. OBTAIN MEDICAL
ATTENTION IN ALL CASES. TREAT SYMPTOMATICALLY & SUPPORTIVELY.
===================== Fire Fighting Measures =====================
Flash Point:103F
Lower Limits:5.4
Upper Limits:16
Extinguishing Media:SMALL FIRES: DRY CHEMICAL, CO2, WATER
SPRAY/ALCOHOL-RESISTANT FOAM
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING & SELF CONTAINED
BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:REACTS W/MOST METALS TO FORM HIGHLY
FLAMMABLE HYDROGEN GAS WHICH CAN FORM EXPLOSIVE MIXTURES W/AIR.
AUTOIGNITION TEMP: 800F.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB W/INERT MATERIAL, DRY SAND/EARTH, THEN
PLACE INTO A CHEMICAL WASTE CONTAINER. USE WATER SPRAY TO DILUTE
LEAK TO A NON-FLAMMABLE MIXTURE. AVOID RUNOFF INTO STORM SEWERS &
DITCHES WHICH LEAD TO W ATERWAYS. REMOVE ALL IGNITION SOURCES.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL/DRY/WELL-VENTILATED
AREA AWAY FROM INCOMPATIBLE SUBSTANCES. STORE IN A SUITABLE
CONTAINER IN A DRY AREA >THE PRODUCT'S FREEZING POINT.
Other Precautions:USE W/ADEQUATE VENTILATION. EMPTY CONTAINERS RETAIN
PRODUCT RESIDUE & CAN BE DANGEROUS. DON'T
PRESSURIZE/CUT/WELD/BRAZE/SOLDER/DRILL/GRIND/EXPOSE SUCH CONTAINERS
TO HEAT/SPARKS/OPEN FLAMES. DON'T GET ON SKIN/EYES. AVOID
INGESTION/INHALATION
============= Exposure Controls/Personal Protection =============
Respiratory Protection:ALWAYS USE A NIOSH-APPROVED RESPIRATOR WHEN
NECESSARY.
Ventilation:ADEQUATE GENERAL/LOCAL EXHAUST VENTILATION TO KEEP AIRBORNE
CONCENTRATIONS <THE PELS.
Other Protective Equipment:PROTECTIVE CLOTHING TO PREVENT SKIN
EXPOSURE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:244F
Melt/Freeze Pt:M.P/F.P Text:62F
Vapor Pres:11.4
Vapor Density:2.1
Spec Gravity:1.05
pH:2.4
Evaporation Rate & Reference:(N-BUTYL ACETATE=1): 0.97
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS LIQUID W/PUNGENT (VINEGAR) ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACETALDEHYDE, 2-AMINOETHANOL, AMMONIUM NITRATE, BROMINE PENTAFLUORIDE,
CHLORINE TRIFLUORIDE, CHLOROSULFONIC ACID (SUPP)
Stability Condition to Avoid:FREEZING, EXCESSIVE HEAT, SPARKS, FLAMES &
OTHER IGNITION SOURCES
Hazardous Decomposition Products:CO, CO2, HYDROGEN GAS
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:29324000, NICKEL CADMIUM BATTERY, SEALED
Preparer's Name:CHARLES MONAHAN
CAGE:0J4G8
AMER
CAGE:0J4G8
Contract Num:SP0430-98-M-JB01
CAGE:7F580
CAGE:0AZF3
============= Composition/Information on Ingredients =============
Ingred Name:NICKEL
CAS:7440-02-0
RTECS #:QR5950000
Minumum % Wt:15.
Maxumum % Wt:30.
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3
Ingred Name:FERRO METAL
Minumum % Wt:35.
Maxumum % Wt:45.
Ingred Name:CADMIUM
CAS:7440-43-9
RTECS #:EU9800000
Minumum % Wt:15.
Maxumum % Wt:25.
OSHA PEL:SEE 1910.1027
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:COBALT
CAS:7440-48-4
RTECS #:GF8750000
< Wt:.5
OSHA PEL:0.1 MG/M3
ACGIH TLV:0.02 MG/M3
Ingred Name:MYLON (PP)
< Wt:3.
Ingred Name:ORGANIC MATERIAL
< Wt:1.
Ingred Name:POTASSIUM HYDROXIDE
CAS:1310-58-3
RTECS #:TT2100000
< Wt:10.
ACGIH STEL:C2 MG/M3
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:FLUORIC RESINS
Minumum % Wt:.05
Maxumum % Wt:.2
===================== Hazards Identification =====================
Health Hazards Acute and Chronic:THERSE ARE SEALED NICKEL CADMIUM
BATTERIES. THEY AARE CLASSIFIED AS AN "ARTICLE" AND ARE
NON-HAZARDOUS UNDER NORMAN USAGE CONDITIONS. SEVERELY OVERCHARGED
OR ABUSED BATTERIES MAY LEAK SMALL AMOUNTS OF ELECTROLYTE. IN
CASE OF SKIN EXPOSURE. WASH ANY EXPOSED SKIN WITH COPIOUS AMOUNTS
HANDLING LEAKING BATTERIES.
Effects of Overexposure:IRRITATION.
======================= First Aid Measures =======================
First Aid:IN CASE OF SKIN EXPOSURE, WASH THE AREA WITH COPIOUS AMOUNTS
HANDLING LEAKING BATTERIES.
================== Accidental Release Measures ==================
Spill Release Procedures:NICKEL CADMIUM BATTERIES DO NOT LEAK
ELECTROLYTE UNDER NORMAL USAGE CONDITIONS. . IT IS ADVISED TO WEAR
SAVE IN PLASIC BAGS OR IN DIS POSAL CONTAINERS.
Neutralizing Agent:DILUTE SOLUTION OF VINEGAR.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A DRY PLACE AT ROOM
TEMPERATURE.
Other Precautions:ASSURE PROPER RECYCLING! ALL PANASONIC NICKEL CADMIUM
BATTERIES ARE COVERED BY THE RECHARGEABLE BATTERY RECYCLING
CORPORATION'S (RBRC) NICKEL CADMIUM BATTERY RECYCLING PROGRAM.
PLEASE CALL 1-800-8-BAT TERY FOR INFORMATION ON RECYCLING USED
NICKEL CADMIUM BATTERY OR GO TO RRC WEB SITE AT WWW.RBRC.ORG FOR
ADDITIONAL INFO.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED.
Ventilation:NORMAL WORK AREA VENTILATION IS ADEQUATE.
Other Protective Equipment:NONE NORMALLLY REQUIRED.
Work Hygienic Practices:IN CASE OF SKIN EXPOSURE, WASH ANY EXPOSED SKIN
WITH COPIOUS AMOUNTS OF WATER.
Supplemental Safety and Health
BATTERIES REFERENCED HEREIN ARE CLASSIFIED AS AN " ARTICLE" AND ARE NOT
SUBJECT TO OSHA HAZARD COMMUNICATION STANDARD 29 CFR 1910.1200
REQUIREMENT. HENCE A MSDS IS NOT REQUIRED. THIS SHEET IS PROVIDE
AS A SERVICE TO OUR CUSTOMERS.
================== Physical/Chemical Properties ==================
HCC:Z5
==================== Disposal Considerations ====================
Waste Disposal Methods:NICKEL CADMIUM BATTERIES DESTINED FOR RECYCLING
CAN BE MANAGED UNDER THE FEDERAL UNIVERSAL WASTE RULE CODIFIED AT
40 CFR PART 273. DISPOSE ONLY IN ACCORDANCE WITH FEDERAL STATE AND
LOCAL REGULATION. B ATTERIES GENERATED AS A WASTE ARE SUBJECT TO
THE RESOURCE CONSERVATION AND RECOVERY ACT (RCRA) AS A DOO6
(CADMIUM) HAZARDOUS WASTE.
=================== MSDS Transport Information ===================
Transport Information:PANASONIC SEALED NICKEL CADMIUM BATTERIES ARE
CONSIDERED "ARTICLE" AND ARE UNREGULATED FOR TRANSPORTATION BY
U.S. DEPARTMENT OF TRANSPORTATION (DOT). INTERNATIONAL CIVIL
AVIATION ADMINISTRATION (ICAC O), INTERNATIONAL AIR TRANSPORT
ASSOCIATION (IATA) AND INTERNATIONAL MARITIME DANGEROUS GOODS
REGULATIONS (IMDG). AS OF 1/1/1997 IATA REQUIRES BATTERIES BEING
TRANSPORTED BY AIR MUST BE PROTECTED FRO M SHORT-CIRCUITING AND
PROTECTED FROM MOVEMENT THAT COULD LEAD TO SHORT-CIRCUITING. WE
RECOMMEND THESE BATTERIES BE SEPARATED TO PREVENT SHORT-CIRCUITS
AND SECURELY PACKAGED IN ALL TRANSPORTATION MODE S.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MIL-L-7808J, MSDS/PRODUCT NUMBER: 0425921
Preparer's Name:P. A. PARKER MANAGER
CAGE:0DH22
CAGE:0DHB8
CAGE:0DH22
============= Composition/Information on Ingredients =============
Ingred Name:NO HAZARD INGREDIENTS STATED BY MANUFACTURERS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: LOW ORAL AND DERMAL TOXICITY.
MISTS OR FUMES FROM EXCESSIVE HEATING MAY CAUSE EYE AND SKIN
IRRITATION, NAUSEA, VOMITING, RESPIRATORY TRACT IRRITATION.
CHRONIC:NONE SPECIFIED BY MANUFACTURER.
Explanation of Carcinogenicity:NONE OF THE CHEMICALS IN THIS PRODUCT IS
LISTED BY IARC, NTP OR OSHA AS A CARCINOGEN.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF SKIN AND
RESPIRATORY DISORDERS MAY BE AT INCREASED RISK FROM EXPOSURE.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE SUBJECT TO FRESH AIR. EYE: FLUSH WITH
PLENTY OF WATER FOR 15 MINUTES. GET IMMEDIATE MEDICAL ATTENTION.
SKIN: WASH WITH SOAP AND WATER. INGESTION: DO NOT INDUCE VOMITING.
GET IMMEDIA TE MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:400F,204C
Extinguishing Media:USE CARBON DIOXIDE, FOAM, DRY CHEMICAL, OR WATER
FOG.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. AVOID
SPREADING LIQUID AND FIRE BY WATER FLOODING.
Unusual Fire/Explosion Hazard:EXPOSURE TO HEAT BUILDS UP PRESSURE
INCLOSED CONTAINERS. COOL WITH WATER SPRAY.
================== Accidental Release Measures ==================
Spill Release Procedures:COVER WITH AN INERT, ABSORBENT MATERIAL AND
REMOVE TO DISPOSAL CONTAINER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT USE OIL ABOVE THE MAXIMUM
RECOMMENDED OPERATING TEMPERATURE OF 400 F. WIPE UP SPILLS
IMMEDIATELY.
Other Precautions:MAY SOFTEN SOME PLASTIC AND PAINT SURFACES. AVOID EYE
AND SKIN CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF VENTILATION DOES NOT MAINTAIN INHALATION
EXPOSURES BELOW PEL (TLV), USE NIOSH/MSHA APPROVED RESPIRATOR AS
PER CURRENT 29 CFR 1910.134, INSTRUCTIONS/WARNINGS AND
NIOSH-RESPIRATOR SELECTION.
Ventilation:LOCAL AND MECHANICAL EXHAUST ARE RECOMMENDED.
Other Protective Equipment:SAFETY SHOWER AND EYE BATH. OTHER EQUIPMENT
AS REQUIRED TO MINIMIZE EXPOSURE FROM PROLONGED OR REPEATED
CONTACT.
Work Hygienic Practices:WASH THROUGHLY AFTER HANDLING AND BEFORE
EATING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:V6
Boiling Pt:B.P. Text:>450F,>232C
Vapor Pres:<0.1
Vapor Density:>1
Spec Gravity:< 1.0
Evaporation Rate & Reference:SLOWER THAN BU/AC
Solubility in Water:NEGLIGIBLE
Appearance and Odor:STRAW CLEAR LIQUID; MILD ODOR.
Percent Volatiles by Volume:NONE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Hazardous Decomposition Products:TOXIC FUMES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE AND LOCAL LAWS AND REGULATIONS. DO NOT CONTAMINATE
ANY LAKES, STREAMS, PONDS OR UNDERGROUND WATER SUPPLY.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:X-60 SLOW SOLVENT (MAK)
CAGE:0ZP91
CAGE:0ZP91
============= Composition/Information on Ingredients =============
Ingred Name:METHYL N-AMYL KETONE
CAS:110-43-0
RTECS #:MJ5075000
Fraction by Wt: 60-100%
Other REC Limits:465MG/M3(TWA)C700MG/
OSHA PEL:100 PPM(TWA) C 150PM
ACGIH TLV:50PPM(TWA)
===================== Hazards Identification =====================
LD50 LC50 Mixture:*
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:UNKNOWN IARC:UNKNOWN OSHA:NO
Health Hazards Acute and Chronic:EYES: SEVERE/CHRONIC IRRITATION,
REDNESS, WTRING, INFLAMATION, ITCHING. SKIN: HARMFUL IF ABSORBED,
INFLAMATION, IRRITATION, DESTRUCTION, DERMOTITIS, INGEST: CHEM
BURNS IRRITATION, MAY BE FATAL, INJ URY MAY BE SEVERE,
INHALE:SEVERE/CHRONIC IRRITATION.MUCUOUSMEMBRANE IRRITANT, MAY
BE FATAL. ION,
Effects of Overexposure:TOXIC TO MUCUOUS MEMBRANES, UPPER RESP TRACT,
LUNGS, BLOOD, KIDNEY, LIVER, PERMIINANT CNS DAMAGE, NAUSEA,
HEADACHE, VOMETING. DANGEROUS IN CASE OF SKIN/EYE CONTACT,
(IRRITANT PERMIATOR), VRY SLIG HTLY TO SLIGHTLY DANG AS, NARCOTIC
Medical Cond Aggravated by Exposure:SKIN/ASTHMA TYPE CONDTTIONS,
======================= First Aid Measures =======================
First Aid:EYES: REMOVE CONTACTS, IMMLY FLUSH W/RUNNING WTR >15 MIN
HOLDING EYELIDS OPEN. DO NOT USE OINTMENT, GET MED AID. SKIN: WASH
W/RUNING WTR/NON-ABRASIVE SOAP 15-30 MIN. HAND CREAM AFTER WASHING.
GET MED AID WASH CONTAM CLOTHING.INHALE: REMOVE TO FRESH AIR.
GET IMMED MED AID, CPR, GET MED AID. INGEST: DO NOT INDUCE VOMET,
IF CONSC, DRINK SEV GLASSES WTR/MLK, GET IMMED MED AID, AVOID
ASPIRATION
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:102.2F24.0C
Autoignition Temp:Autoignition Temp Text:739.4F
Lower Limits:1.1
Upper Limits:7.9
Extinguishing Media:SM FIRE: DRY CHEM, CO2 ALC FOAM, WTR SPRA, LG
FIRE: WTR SPRA OR FOG, NEVER DIRECT WTR JET INSIDE CONTAINER
Fire Fighting Procedures:COOL CONT W/WTR SPRA/FOG, WEAR SCUBA VPR MAY
TRAVL LONG DISTANCES TO SOURCE OF IGNTN AND FLASH BACK. EMITS
HIGHLY TOXIC FUMES. CONT MAY EXPLD DUE TO HEAT
Unusual Fire/Explosion Hazard:VPR FORMS EXPLOSIVE MIXTURE W/AIT BTWN
LEL AND UEL LIQUID WILL FLOAT AND MAY IGNITE ON SURFACE OF WTR
================== Accidental Release Measures ==================
Spill Release Procedures:SM: ABSORB W/INERT MATL. PLACE IN CONT. LRG:
ELIM ALL IGNITBLESWEAR FULL-PROT EQUIP STOP LEAK PREVENT ENTRY
INTO SEWERS/ALL WATRWAYS, CALL FOR ASSISTANCE ON DISPOSAL
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN SEPARATE SAFETY RM. AVOID ALL
IGNITS, KEEP CONT TIGHTLY CLOSED IN WELL VENTED DRY PLACE, REFRIG
PREF. AVOID INCOMPATIBLES
Other Precautions:KEEP OUT OF REACH OF CHILDREN, AVOID ALL CONTACT
W/PRODUCT. NO CONTACT LENSES, SHOW LABEL TO MED AID. GROUND AL
EQUIP. ISOCYANATES CAN NOT BE SMELLED UNTIL WELL ABV SAFE EXPOSURE
LIMIT
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APRVD VPR/DUST RESPIRATOR, (W/ORGANIC
VPR CARTRAGES, SCUBA/AIR SUPPLIED RESPIRATOR, IN SPRAY APPLICATION,
AIR PURIFYING RESP W/ORGANIC VPR CARTRIDGE/PARTICULATE PREFILTERS
Ventilation:EXHAUST VENTILATION, DO AIR MONITORING IF POSSIBLE
Other Protective Equipment:EYE WASH STATION, SAFETY SHOWER, FULL SUIT,
BOOTS, LAB COAT
Work Hygienic Practices:KEEP PROD AWAY FROM FOOD, DRINKS, TOBACCO,
EATING, DRINKING, SMOKING SHD BE PROHIB AROUND PRODUCT. WASH
HANDS, FACE
Supplemental Safety and Health
METH-N-AMYL KETONEE: LD50MG/KG ORAL, ACUTE 1670 RAT, DERMAL ACUTE 12600
RABBIT VAPOR (LC50-PPM ACUTE 3000 RAT
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:305.6F39C
Vapor Pres:2.1
Vapor Density:3.94
Spec Gravity:.81
Evaporation Rate & Reference:0.4
Solubility in Water:INSOLUABLE
Appearance and Odor:CLEAR LIQUID
Percent Volatiles by Volume:100%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
HIGHLY REACTIVE W/OXYDIZING AGENTS, SLIGHTLY REACTIVE TO REACTIVE
W/REDUCING AGENTS, ORGANIC MTLS, METALS, ALKALI,ACIDS
Hazardous Decomposition Products:CO CO2
==================== Disposal Considerations ====================
Waste Disposal Methods:HAZARDOUS WASTE. FILL DRUMS HALFWAY, DO NOT
SEAL. KEEP WELL VENTED. PER FED STATE LOCAL REGS, AVOID RESIDUE.
DO NOT HEAT/CUT EMPTY CONTS W/ELECT/GAS TORCH
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:HI-SPOT BLUE BASE 107, .22 OZ TUBE - 83207
CAGE:ITWFL
CAGE:98148
CAGE:ITWFL
============= Composition/Information on Ingredients =============
Ingred Name:NON-HAZARDOUS INGREDIENTS
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:VOLATILE ORGANIC COMPOUNDS (COATING & MATERIAL): 0.00
LB/GAL.
RTECS #:9999999VO
Ingred Name:SUPP DATA:ELEVATED-TEMP PROCESS CNDTNS, ESP IN PROCESSES
OPERATING UNDER VACUUM IF SUBJECTED TO SUDDEN INGRESS OF(ING 4)
RTECS #:9999999ZZ
Ingred Name:ING 3:AIR/OUTSIDE PROCESS EQUIP OPERATING UNDER ELEVATED
PRESS IF SUDDEN ESCAPE OF VAPS/MISTS TO ATM OCCURS.
RTECS #:9999999ZZ
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:SLIGHT IRRITATION. INHAL:HIGH
CONCENTRATIONS OF VAPORS MAY PRODUCE IRRITATION OF THE RESPIRATORY
TRACT, HEADACHE, DIZZINESS & NAUSEA. SKIN/EYE CONTACT:SLIGHT
IRRITATION. SKIN ABSORPTION:SLIGHT I RRITANT. INGEST:NO DATA.
CHRONIC:EFFECTS ARE NOT KNOWN.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:SKIN DISORDERS.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD IMMEDIATELY . KEEP HEAD BELOW HIPS TO PREVENT
ASPIRATION OF LIQUID INTO LUNGS. INHAL:REMOVE TO FRESH AIR. SUPPORT
BREATHING (GIVE O*2/ARTF RESP) . EYES:FLUSH WELL W/WATER FO R AT
LEAST 15 MINUTES. CONTACT MD IRRITATION PERSISTS. SKIN:WASH W/SOAP
& WATER.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:300F,149C
Extinguishing Media:CO*2, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:PREVENT SKIN & EYE CONTACT. USE
NON-COMBUSTIBLE MATERIAL TO CONFINE &/OR ABSORB. ELIMINATE IGNITION
SOURCES. VENTILATE AREA.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:ANY PROPOSED USE OF THIS PROD IN
ELEVATED-TEMP PROCESSES SHOULD BE THORO EVALUATED TO ASSURE THAT
SAFE OPERATING CNDTNS ARE ESTABLISHED & MAINTAINED.
Other Precautions:'EMPTY' CNTNRS RETAIN RESIDUE (LIQ &/OR VAP) & CAN BE
DANGEROUS. DO NOT PRESSURIZE, CUT, WELD, BRAZE, SOLDER, DRILL,
GRIND/EXPOSE SUCH CNTNRS TO HEAT, SPKS, FLAMES, STATIC ELEC/OTHER
SOURCES OF IGNIT. WARNING:MANY HOT ORG CHEM VAPS/(SUPDAT)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN . NONE REQUIRED AT NORMAL HANDLING
TEMPERATURES.
Ventilation:LOCAL EXHAUST IS RECOMMENDED FOR CONFINED AREAS. GENERAL
MECHANICAL VENTILATION IS ADEQUATE FOR NORMAL USE.
Other Protective Equipment:ANSI APPROVED EYE BATH & SAFETY SHOWER.
OTHER PROTECTIVE GEAR AS REQUIRED TO MINIMIZE SKIN CONTACT.
Work Hygienic Practices:FOLLOW CURRENT H.M.I.S. REGULATIONS.
Supplemental Safety and Health
OTHER PREC:MISTS ARE SUSCEPTIBLE TO SUDDEN SPONT COMBUST WHEN MIXED
W/AIR. IGNIT MAY OCCUR AT TEMPS BELOW THOSE PUBLISHED IN LITERATURE
AS "AUTOIGNIT"/"IGNIT" TEMPS. IGNIT TEMPS DECR W/INCR VAP VOL, &
VAP VOL & VAP/AIR CONT TIME, & ARE INFLUENCED BY PRESS CHANGES.
IGNIT OF ORG CHEM VAPS MAY OCCUR AT TYPICAL (ING 3)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:547F,286C
Vapor Density:>1
Spec Gravity:0.92 (H*2O=1)
Evaporation Rate & Reference:<1 (BUTYL ACETATE=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:BLUE OPAQUE PASTE LIKE SOLID W/PETROLEUM OIL ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:OXIDES OF CARBON.
==================== Disposal Considerations ====================
Waste Disposal Methods:REMOVE TO A WASTE DISPOSAL FACILITY OPERATING IN
COMPLIANCE W/FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:ANTISEPTIC HAND CLEANER, 71017
CAGE:5L381
CAGE:5L381
============= Composition/Information on Ingredients =============
Ingred Name:STODDARD SOLVENT; (MINERAL SPIRITS). LEL: 0.8%.
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 40-45%
OSHA PEL:500 PPM
ACGIH TLV:100 PPM; 9293
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 35-40%
Ingred Name:FATTY ACID SOAPS
Fraction by Wt: 5-11%
Ingred Name:SURFACTANT (NON-IONIC); (NONIONIC SURFACTANT)
Fraction by Wt: 2-8%
Ingred Name:1,2-PROPANEDIOL; (ALKYLENE DIOL)
CAS:57-55-6
RTECS #:TY2000000
Fraction by Wt: 2-5%
Ingred Name:3,5-XYLENOL,4-CHLORO; (P-CHLORO-M-XYLENOL)
CAS:88-04-0
RTECS #:ZE6850000
Fraction by Wt: 0.5-1.5%
Ingred Name:ALOE, PHARMACEUTICAL; (ALOE VERA)
CAS:8001-97-6
RTECS #:BC8055000
Fraction by Wt: TRACE
Ingred Name:FRAGRANCE
Fraction by Wt: TRACE
Ingred Name:LANOLIN
CAS:8006-54-0
Fraction by Wt: TRACE
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50: ORAL =>5000 MG/KG.
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NONE SPECIFIED BY MANUFACTURER.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:NONE UNDER NORMAL CONDITIONS OF USE.
Medical Cond Aggravated by Exposure:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH AT LEAST 15 MINUTES WITH WATER. CALL MD
IMMEDIATELY. SKIN: WASH W/SOAP & WATER. INHAL: REMOVE TO FRESH AIR.
IF SYMPTOMS PERSIST, OBTAIN MEDICAL ATTENTION. INGEST: DO NOT
INDUCE VOMITING. C ALL MD IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:124F,51C
Lower Limits:SEE ING 1
Extinguishing Media:CARBON DIOXIDE, CHEMICAL POWDER.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED PRESSURE DEMAND SCBA
& FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:RINSE AWAY WITH WATER OR WIPE UP WITH A TOWEL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:HAND CLEANER SHLD BE STORED BETWEEN
40F-100F IN ORDER TO INSURE LONG LIFE OF EMULSION. KEEP AWAY FROM
SPARKS/OPEN FLAME. FOLLOW ALL GEN SAFETY PREC.
Other Precautions:KEEP AWAY FROM CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED SELF-CONTAINED BREATHING
APPARATUS IS REQUIRED SHOULD TLV BE EXCEEDED.
Ventilation:LOCAL EXHAUST SUFFICIENT TO MAINTAIN VAPOR CONCENTRATION
BELOW TLV.
Other Protective Equipment:NONE NORMALLY NEEDED.
Work Hygienic Practices:USE AS DIRECTED ON PRODUCT LABEL.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:F4
Spec Gravity:0.85
pH:8.6
Solubility in Water:SOLUBLE
Appearance and Odor:WHITE CREAM, ANTISEPTIC ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:KEEP AWAY FROM SPARKS OR OPEN FLAME.
Hazardous Decomposition Products:IRRITATING ORGANIC VAPORS (BY FIRE OR
THERMAL DECOMPOSITION).
==================== Disposal Considerations ====================
Waste Disposal Methods:NORMAL REFUSE OR SEWAGE. FOLLOW EPA AND LOCAL,
STATE, AND FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:330 LIME
CAGE:HO829
CAGE:84021
CAGE:HO829
============= Composition/Information on Ingredients =============
Ingred Name:MANGANESE (SARA 313)
CAS:7439-96-5
RTECS #:OO9275000
Fraction by Wt: 2%
OSHA PEL:C 5 MG/M3 DUST
ACGIH TLV:5 MG/M3 DUST
Ingred Name:NICKEL (SARA 313) (CERCLA)
CAS:7440-02-0
RTECS #:QR5950000
Fraction by Wt: 25-28%
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3
Ingred Name:CHROMIUM (SARA 313) (CERCLA)
CAS:7440-47-3
RTECS #:GB4200000
Fraction by Wt: 11-13%
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:CALCIUM FLUORIDE (AS F); (CAF2)
CAS:7789-75-5
RTECS #:EW1760000
OSHA PEL:2.5 MG/M3 (MFR)
ACGIH TLV:2.5 MG/M3 (MFR)
Ingred Name:CALCIUM CARBONATE; (CACO3)
CAS:1317-65-3
RTECS #:EV9580000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:SILICA, CRYSTALLINE - QUARTZ; (SIO2)
CAS:14808-60-7
RTECS #:VV7330000
OSHA PEL:SEE TABLE Z-3
ACGIH TLV:0.1 MG/M3 RDUST
Ingred Name:SILICON; (SI)
CAS:7440-21-3
RTECS #:VW0400000
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:SILICIC ACID (H2SIO3), DISODIUM SALT
CAS:6834-92-0
RTECS #:VV9275000
OSHA PEL:5 MG/M3 (MFR)
ACGIH TLV:10 MG/M3 (MFR)
Ingred Name:SILICATE BINDERS
CAS:10006-28-7
OSHA PEL:5 MG/M3 (MFR)
ACGIH TLV:10 MG/M3 (MFR)
Ingred Name:IRON
CAS:7439-89-6
RTECS #:NO4565500
OSHA PEL:10 MG/M3 (MFR)
ACGIH TLV:5 MG/M3 (MFR)
Ingred Name:HAZ DECOMP PROD: VOLAT, RXN/OXIDATION OF INGS, PLUS THOSE
FROM MATL BEING WORKED & COATINGS ETC, NOTED ABOVE. (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11: REASONABLY EXPECTED DECOMP PRODS FROM NORM USE OF
THESE PRODS INCL COMPLEX OF OXIDES & FLUORIDES OF (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12: MATLS LISTED IN INGS SECTION, AS WELL AS CARBON
MONOXIDE & DIOXIDE, OZONE & NITROGEN OXIDES. THE ONLY (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13: WAY TO DETERMINE TRUE IDENTITY OF DECOMP PRODS IS
BY SAMPLING & ANALYSIS. CONT NEHC FOR MORE INFO .
RTECS #:9999999ZZ
Ingred Name:EXPLAN OF CARCIN: SILICA, CRYSTALLINE-QUARTZ: IARC
MONOGRAPHS, VOLUME 68, 1997: GROUP 1. NTP 7TH ANNUAL REPORT (ING
16)
RTECS #:9999999ZZ
Ingred Name:ING 15: ON CARCINOGENS, 1994: ANTICIPATED TO BE CARCINOGEN.
HUMAN: LUNG.
RTECS #:9999999ZZ
Ingred Name:EFTS OF OVEREXP: CHEST PAIN. CHROMIUM/CHROMATE IN FUME CAN
CAUSE IRRIT OF NASAL MEMB & SKIN. NICKEL CMPDS IN (ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17: FUME CAN CAUSE METALLIC TASTE, NAUS, TIGHTNESS OF
CHEST, FEVER & ALLERGIC RXN. CHRONIC OVEREXP TO AIR (ING 19)
RTECS #:9999999ZZ
Ingred Name:ING 18: CONTAMINANTS MAY LEAD TO THEIR ACCUM IN LUNGS, A
CNDTN WHICH MAY BE SEEN AS DENSE AREAS ON CHEST X-RAYS.(ING 20)
RTECS #:9999999ZZ
Ingred Name:ING 19: SEV OF CHANGES IS PROPORTIONAL TO LENGTH OF EXPOS.
CHANGES SEEN ARE NOT NEC ASSOC W/SYMPS/SIGNS OF (ING 21)
RTECS #:9999999ZZ
Ingred Name:ING 20: REDUCED LUNG FUNC/DISEASE. IN ADDN, CHANGES ON
X-RAYS MAY BE CAUSED BY NON-WORK FACTORS SUCH AS SMKNG, (ING 22)
RTECS #:9999999ZZ
Ingred Name:ING 21: ETC. NICKEL & CHROMIUM ARE CONSIDERED CARCIN. LONG
TERM OVEREXP TO NICKEL FUMES MAY ALSO CAUSE PULM (ING 23)
RTECS #:9999999ZZ
Ingred Name:ING 22: FIBROSIS & EDEMA. OVEREXP TO MANGANESE CMPDS MAY
AFFECT CNS, SYMPS OF WHICH ARE LANGUOR, SLEEPINESS, (ING 24)
RTECS #:9999999ZZ
Ingred Name:ING 23: MUSCULAR WEAKNESS, EMOTIONAL DISTURBANCES AND
SPASTIC GAIT.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC: INGEST: CALL MD IMMED . SKIN: FLUSH WITH
COPIOUS AMOUNTS OF WATER. SEE MD .
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ELEC ARC WORKING MAY CREATE ONE/MORE
OF THE FOLLOWING HLTH/PHYSICAL HAZS. FUMES & GASES CAN BE DANGEROUS
TO YOUR HLTH. ELEC SHOCK CAN KILL. ARC RAYS CAN INJURE EYES & BURN
SKIN. NOISE CAN DMG HEARING. WHEN THESE PRODS ARE USED AS REC BY
MFR, & VENT MAINTAINS EXPOS TO DECOMP PRODS BELOW LIMITS REC, (EFTS
OF OVEREXP)
Explanation of Carcinogenicity:NICKEL: IARC MONO, VOL 49, PG 257, 1990:
GROUP 2B. NTP 7TH ANNUAL RPT ON CARCINS, 1994: ANTIC TO BE CARCIN.
(ING 15)
Effects of Overexposure:HLTH HAZ: OVEREXP IS UNLIKELY. ACUTE OVEREXP TO
GASES, FUMES & DUSTS MAY INCL IRRIT OF EYES, LUNGS, NOSE & THROAT.
SOME TOX GASES ASSOC W/WELDING MAY CAUSE PULM EDEMA, ASPHY & DEATH.
ACUTE OVEREXP MAY INCL SIGNS & SYMPS SUCH AS WATERY EYES, NOSE &
THROAT IRRIT, HDCH, DIZZ, DFCLTY IN BRTHG, FREQUENT COUGHING,
OR(ING 17)
Medical Cond Aggravated by Exposure:PERS W/ALLERGIES/IMPAIRED RESP
FUNCTION MAY HAVE SYMPS WORSENED BY EXPOS TO WELDING FUMES.
HOWEVER, SUCH REACTION CANNOT BE PREDICTED DUE TO VARIATION IN
COMPOSITION & QUANTITY OF DECOMPOSITION PRODS.
======================= First Aid Measures =======================
First Aid:IN CASE OF EMER, CALL FOR MED AID. EMPLOY FIRST AID
TECHNIQUES REC BY RED CROSS. INHAL: IF BRTHG IS DFCLT, GIVE OXYGEN
& CALL FOR MD. ELEC SHOCK: DISCONNECT & TURN OFF POWER. IF NOT
BRTHG, BEGIN ARTF RESP, PREF MOUTH-TO-MOUTH. IF NO DETECTABLE
PULSE, BEGIN CPR. IMMED CALL MD. ARC BURN: APPLY COLD, CLEAN
COMPRESSES & CALL MD. EYES: FLUSH W/POTABLE WATER FOR AT LEAST 15
MIN. SEE MD . (ING 25)
===================== Fire Fighting Measures =====================
Extinguishing Media:PROD WILL NOT BURN. HOWEVER, WELDING ARCS & SPKS
CAN IGNITE COMBUST & FLAM MATLS. USE EXTING MEDIA REC FOR (SUP DAT)
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:AS SHIPPED, THESE PRODUCTS ARE
NON-FLAMMABLE, NON-EXPLOSIVE, NON-REACTIVE, AND NON-HAZARDOUS. ONLY
THE PACKAGING FOR THIS PRODUCT WILL BURN.
================== Accidental Release Measures ==================
Spill Release Procedures:NOT APPLICABLE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:TRAIN THE WELDER NOT TO TOUCH LIVE
ELECTRICAL PARTS, TO INSULATE HIMSELF FROM WORK AND GROUND, AND TO
KEEP HIS HEAD OUT OF FUMES.
Other Precautions:READ & UNDERSTAND MFR'S INSTRUCTIONS & PREC LABEL ON
PROD. SEE AMERICAN NATL STD Z-49.1, "SFTY IN WELDING & CUTTING",
PUBLISHED BY AMERICAN WELDING SOCIETY, & OSHA PUBLICATION 2206
(29CFR 1910). CONTNEHC FOR MORE SPECIFIC INFO .
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED RESPIRABLE FUME RESPIRATOR OR
AIR SUPPLIED RESPIRATOR WHEN WELDING IN CONFINED SPACE OR WHERE
LOCAL EXHAUST OR VENTILATION DOES NOT KEEP EXPOSURE BELOW TLV.
Ventilation:USE ENOUGH VENT, LOCAL EXHAUST AT ARC/BOTH, TO KEEP FUMES &
GASES BELOW TLV IN WORKER'S BREATHING ZONE & GEN ARC AREA.
Other Protective Equipment:ANSI APPROVED EMERGENCY EYEWASH AND DELUGE
SHOWER . ARM PROTECTORS, APRONS, HATS, DARK CLOTHING.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EXTING MEDIA: BURNING MATLS & FIRE SITUATION. SEE ANSI Z49.1 "SFTY IN
WELDING & CUTTING" & "SAFE PRACT" CODE: SP, PUBLISHED BY AMERICAN
WELDING SOCIETY, P.O. BOX 351040, MIAMI, FL 33135, & NFPA 51B "C
UTTING & WELDING PROCESSES", PUBLISHED BY NATL FIRE PROT ASSOC,
BATTERYMARCH PARK, QUINCY, MA 02269 FOR ADDNL INFO.
================== Physical/Chemical Properties ==================
HCC:T6
Appearance and Odor:SOLID STAINLESS STEEL CORE WIRE WITH FLUX COATING,
ODORLESS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE CURRENTLY KNOWN.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:WELDING FUMES & GASES CANNOT BE
CLASSIFIED SIMPLY. DECOMP PRODS OF NORM OPERATION INCL THOSE
ORIGINATING FROM (ING 11)
==================== Disposal Considerations ====================
Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT, RESIDUE, DISPOSABLE CONTAINER, OR
LINER IN AN ENVIRONMENTALLY ACCEPTABLE MANNER, IN FULL COMPLIANCE
WITH FEDERAL, STATE A ND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:RANITIDINE HYDROCHLORIDE
CAGE:34006
CAGE:34006
============= Composition/Information on Ingredients =============
Ingred Name:RANITIDINE HYDROCHLORIDE *95-1*
CAS:70956-04-6
RTECS #:KM6557000
Fraction by Wt: 100%
OSHA PEL:0.05 MG/M3
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: IRRITATION, SENSITIZATION.
INHALATION: IRRITATION OF THE MUCOUS MEMBRANES. EYES: IRRITATION.
INGESTION: ADVERSE EFFECTS THAT HAVE BEEN OBSERVED W/RAINITIDINE
USED CLINICALLY ARE REVERSIBLE INFLA MMATION OF THE LIVER WHICH MAY
BE ACCOMPANIED BY JAUNDICE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, RASH, SHORTNESS OF BREATH,
WHEEZING, ITCHY RASH, NASAL CONGESTION, RUNNY NOSE, HEADACHE,
JAUNDICE.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/LARGE AMOUNTS OF WATER. SKIN: WASH W/SOAP &
WATER. INHALATION: REMOVE TO FRESH AIR. GIVE OXYGEN/CPR IF NEEDED.
INGESTION: RINSE MOUTH, GIVE LARGE QUANTITIES OF WATER & ENCOURAGE
VOMITING . OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER SPRAY, FOAM, MULTI-PURPOSE DRY CHEMICAL
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING & USE A SELF
CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:AS W/ANY ORGANIC DUST, THERE IS POTENTIAL
FOR EXPLOSION WHEN SUSPENDED IN AIR IN HIGH CONCENTRATIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR FULL PROTECTIVE EQUIPMENT. COLLECT BY
CAREFULLY SWEEPING/VACUUMING W/HEPA FILTERED VACUUM & PLACE IN
LABELED, SEALED CONTAINER FOR REUSE/DISPOSAL. WASH AREA W/WATER
AFTER VACUUMING.
======================Handling and Storage ======================
Handling and Storage Precautions:USE PRACTICES THAT WILL MINIMIZE
GENERATION OF DUST.
Other Precautions:AVOID BODY CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RECOMMENDED BY NIOSH/MSHA.
Ventilation:LOCAL EXHAUST VENTILATION
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:272F
Solubility in Water:COMPLETE
Appearance and Odor:OFF-WHITE TO PALE YELLOW COLORED POWDER
W/CHARACTERISTIC SULFUR-LIKE ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:EXTREME HEAT, TEMP >300F.
Hazardous Decomposition Products:TOXIC/CORROSIVE VAPORS, CHLORIDES,
OXIDES OF NITROGEN & SULFUR
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE AT AN APPROVED FACILITY IAW/FEDERAL,
STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CMS FORMALIN 10%,BUFFERED
CAGE:36953
CAGE:36953
============= Composition/Information on Ingredients =============
Ingred Name:FORMALDEHYDE (SARA III)
CAS:50-00-0
RTECS #:LP8925000
Fraction by Wt: 4.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:SEE 1910.1048
ACGIH TLV:C 0.3 PPM; A2; 9293
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:ACGIH TLV/STEL: 0.75 PPM/2 PPM
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:(ACUTE AND CHRONIC): POISONOUS IF
SWALLOWED. SWALLOWING MAY CAUSE BURNING IN MOUTH, VOMITING,
ABDOMINAL PAIN AND DIARRHEA. DEATH MAY RESULT. CHRONIC:
FORMALDEHYDE IS A MUTAGENIC, AVOID EXPOSURE TO HIG H
CONCENTRATIONS.
Explanation of Carcinogenicity:CONTAINS F [50-00-0] WHICH IS
LISTED BY NTP AND IARC AND REGULATED BY OSHA AS A CARCINOGEN.
Effects of Overexposure:IRRITATION OF SKIN, EYES, NOSE, THROAT AND
UPPER RESPIRATORY TRACT.
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH PREEXISTING
DISEASES OF THE LUNGS AND SKIN MAY BE AT INCREASED SUSCEPTIBILITY
TO THE TOXICITY OF EXCESSIVE EXPOSURE.
======================= First Aid Measures =======================
First Aid:SKIN: REMOVE CONTAMINATED CLOTHING; WASH AREA WITH SOAP AND
WATER. EYES: FLUSH WITH WATER FOR 15 MINUTES. CALL PHYSICIAN IF
IRRITATION PERSISTS. INGEST: DILUTE WITH WATER, MILK OR ACTIVATED
CHARCOAL. INDUCE VOMITING IF POSSIBLE. CONTACT A PHYSICIAN
IMMEDIATELY. INHALATION: REMOVE TO FRESH AIR. IF BREATHING HAS
STOPPED BEGIN ARTIFICIAL RESPIRATION. CONTACT A PHYSICIAN
IMMEDIATELY.
===================== Fire Fighting Measures =====================
Extinguishing Media:DRY POWDER, FOAM, CARBON DIOXIDE, AND WATER SPRAY.
Fire Fighting Procedures:USE A SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:MAY EMIT TOXIC FUMES UNDER FIRE
CONDITIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROPER SAFETY EQUIPMENT. WIPE UP WITH
DAMP MOP OR SPONGE. FOR LARGER SPILLS ABSORB LIQUID WITH SAND OR
SIMILIAR MATERIAL.
Neutralizing Agent:NONE
======================Handling and Storage ======================
Handling and Storage Precautions:NORMAL STORAGE CONDITIONS FOR
CHEMICALS. OPEN ONLY IN VENTILATED AREAS.
Other Precautions:VAPORS COULD BE STRONG IN NON-VENTILATED AREAS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NORMALLY REQUIRED.IF VAPOR CONCENTRATION
BECOMES HIGH, USE NIOSH APPROVED.
Ventilation:LOCAL EXHAUST.
Other Protective Equipment:NORMAL LABORATORY APPAREL.
Work Hygienic Practices:WASH WITH SOAP AND WATER AFTER HANDLING.
Supplemental Safety and Health
THIS NSN WAS CANCELLED AS OF 90182.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:79 MMHG
Vapor Density:>1
Spec Gravity:1.07
Evaporation Rate & Reference:SIMILAR TO WATER
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, COLORLESS LIQUID, PUNGENT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CAUSTIC SODA, ASH, ALKALIS, AMINES, ACIDS AND STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HIGH HEAT. KEEP CONTAINERS TIGHTLY SEALED.
Hazardous Decomposition Products:CARBON DIOXIDE,CARBON MONOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE AND
LOCAL REGULATIONS. FORMALDEHYDE IS CONSIDERED A HAZARDOUS WASTE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:PRIMER B50Y1 ZINC CHROMATE
CAGE:DO642
CAGE:DO642
CAGE:09800
============= Composition/Information on Ingredients =============
Ingred Name:KEROSENE (PETROLEUM), HYDROTREATED; (MINERAL SPIRITS).
VP:2.
CAS:64742-47-8
RTECS #:OA5504000
Fraction by Wt: 32%
OSHA PEL:100 PPM (MFR)
ACGIH TLV:100 PPM (MFR)
Ingred Name:TALC (POWDER), CONTAINING NO ASBESTOS FIBERS; (TALC)
CAS:14807-96-6
RTECS #:WW2710000
Fraction by Wt: 31%
OSHA PEL:20 MPPCF
ACGIH TLV:2 MG/M3 RDUST
Ingred Name:CHROMATE (1-), HYDROXYOCTAOXOZINCATEDI-, POTASSIUM;
(POTASSIUM ZINC CHROMATE)
CAS:11103-86-9
RTECS #:GA9170000
Fraction by Wt: 5%
OSHA PEL:N/K
ACGIH TLV:0.05 MG/M3 (MFR)
Ingred Name:CHROMIUM COMPOUND
Fraction by Wt: 1.1%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ZINC COMPOUND
Fraction by Wt: 1.8%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:VOLATILE ORGANIC COMPOUNDS: 3.38 LBS/GAL.
RTECS #:9999999VO
Ingred Name:SUPP DATA:BY DELIBERATELY CONCENTRATING CONTENTS CAN BE
HARMFUL OR FATAL.
RTECS #:9999999ZZ
Ingred Name:WASTE DISP METH:OF I/A/W FEDERAL, STATE & LOCAL REGULATIONS
REGARDING POLLUTION.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC:PROCS. TRANSFER ONLY TO APPRVD CNTNRS W/COPMLETE
& APPROP LABELING. USE ONLY W/ADEQ VENT. AVOID BRTHG(ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9:VAP & SPRAY MIST. AVOID CONT W/SKIN & EYES. THIS
COATING MAY CONTAIN MATLS CLASSIFIED AS NUISANCE (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10:PARTICULATES WHICH MAY BE PRESENT AT HAZ LEVELS ONLY
DURING SANDING/ABRADING OF DRIED FILM. IF NO (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11:SPECIFIC DUSTS ARE LISTED, APPLIC LIMS FOR NUISANCE
DUSTS ARE ACGIH TLV 10 MG/M3 TDUST, OSHA PEL 15 MG/M3(ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12:TDUST, 5 MG/M3 (RESPIRABLE FRACTION).
RTECS #:9999999ZZ
Ingred Name:RESP PROT:MSHA APPROVED PARTICULATE RESPIRATOR FOR
PROTECTION AGAINST NON-VOLATILE MATERIALS IN INGREDIENTS.
RTECS #:9999999ZZ
Ingred Name:VENT:1910.94, 1910.107, 1910.108.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EXPOS MAY BE BY INHAL &/OR SKIN/EYE
CONT, DEPENDING ON CNDTNS OF USE. TO MIN EXPOS, FOLLOW RECS FOR
PROPER USE, VENT & PERSONAL PROT EQUIP. ACUTE:IRRIT OF EYES, SKIN &
RESP SYS. MAY CAUSE NERV SYS DEP RESS. EXTREME OVEREXP MAY RSLT IN
UNCON& POSS DEATH. HDCH, DIZZ, NAUS & LOSS OF COORD ARE INDICATIONS
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:ZINC POTASSIUM CHROMATE:IARC MONOGRAPHS
ON EVALUATION OF CARCINOGENIC RISK OF CHEMS TO MAN, VOL 49, PG 49,
1990:GRP 1.
Effects of Overexposure:HLTH HAZ:OF EXCESSIVE EXPOS TO VAPS/SPRAY
MISTS. REDNESS & ITCH/BURNING SENSATION MAY INDICATE EYE/EXCESSIVE
SKIN EXPOS. CHRONIC:STUDIES HAVE ASSOC EXPOS TO CHROMIUM VI CMPDS
W/INCR RISK OF RESP CANCE R. PRLNG OVEREXP TO SOLV INGS MAY
CAUSEADVERSE EFTS TO LIVER, URINARY & REPRO SYS. RPTS HAVE ASSOC
RPTD & PRLNG(SUPDAT)
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE FROM EXPOSURE. RESTORE BREATHING. KEEP WARM &
QUIET. SKIN:WASH AFFECTED AREA THOROUGHLY W/SOAP & WATER. REMOVE
CONTAMINATED CLOTHING & LAUNDER BEFORE RE-USE. EYES:FLUSH W/LARGE
AMOUNTS OFWATER FOR AT LEAST 15 MINUTES. GET MEDICAL ATTENTION.
INGEST:GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:101F,38C
Lower Limits:0.7%
Upper Limits:6%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:USE NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP.
WATER SPRAY MAY BE INEFT. IF WATER IS USED, FOG NOZZ ARE PREF.
WATER MAY BE USED TO COOL CLSD CNTNRS(SUPDAT)
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM
HEAT, ELEC EQUIP, SPKS & OPEN FLAME. CLSD CNTNRS MAY EXPLODE WHEN
EXPOS TO EXTREME HEAT. APPLICATION TO HOT SURFS(SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE &
REMOVE W/INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DOL STOR CATEGORY - 2. KEEP AWAY FROM
HEAT, SPKS & OPEN FLAME. KEEP CNTNR CLSD WHEN NOT IN USE. DO NOT
TAKE INTERNALLY. KEEP OUT OF REACH OF CHILDREN.
Other Precautions:DURING USE & UNTIL ALL VAPS ARE GONE:KEEP AREA
VENTED; DO NOT SMOKE; EXTING ALL FLAMES, PILOT LIGHTS & HEATERS;
TURN OFF STOVES, ELEC TOOLS & APPLIANCES & ANY OTHER SOURCES OF
IGNIT. CONSULT NFPA CODE . USE APPRVD BONDING & GROUNDING (ING 9)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF PERSONAL EXPOS CANNOT BE CONTROLLED BELOW
APPLIC LIMS BY VENT, WEAR PROPERLY FITTED NIOSH/MSHA APPRVD ORG
VAP/PARTICULATE RESP FOR PROT AGAINST INGS. WHEN SANDING,
WIREBRUSHING, ABRADING, BURNING/W ELDING DRIED FILM, WEAR NIOSH/
(ING 14)
Ventilation:LOC EXHST PREF. GEN EXHST ACCEPT IF EXPOS TO INGS IS
MAINTAINED BELOW APPLIC EXPOS LIMS. REFER TO OSHA STDS (ING 15)
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:WASH HANDS AFTER USING.
Supplemental Safety and Health
FIRE FIGHT PROC:TO PVNT PRESS BUILD-UP & POSS AUTOIGNIT/EXPLO WHEN
EXPOS TO EXTREME HEAT. EXPLO HAZ:REQS SPECIAL PRECS. DURING EMER
CNDTNS OVEREXP TO DECOMP PRODS MAY CAUSE HLTH HAZ. SYMPS MAY NOT BE
IMMED APPARENT. OBTAIN MED ATTN. EFTS OF OVEREXP:OVEREXP TO SOLVS
W/PERM BRAIN & NERV SYS DMG. INTENTIONAL MISUSE(ING 7)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>277F,>136C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:1.24
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:43-62
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:BY FIRE:CARBON DIOXIDE, CARBON
MONOXIDE, OXIDES OF METALS IN INGREDIENTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE FROM THIS PROD MAY BE HAZ AS DEFINED UNDER
RCRA 40 CFR 261. WASTE MUST BE TESTED FOR IGNITABILITY TO DETERMINE
APPLIC EPA HAZ WASTE NUMBERS. MUST ALSO BE TESTED FOR
EXTRACTABILITY. INCIN IN APPR VD FACILITY. DO NOT INCIN CLSD CNTNR.
DISP (ING 8)
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:DIAZENE-42
CAGE:0AP48
CAGE:27368
CAGE:0AP48
============= Composition/Information on Ingredients =============
Ingred Name:ETHYL DIBROMOBENZENE, DIAZENE 42
CAS:30812-87-4
RTECS #:CZ1800000
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: NASAL IRRITATION; POSSIBLE
LIVER/KIDNEY DAMAGE. EYE: NO IRRITATION/CORNEAL INJURY. SKIN:
IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: NASAL IRRITATION; POSSIBLE
LIVER/KIDNEY DAMAGE. SKIN: IRRITATION.
======================= First Aid Measures =======================
First Aid:EYE: IRRIGATE W/LARGE VOLUMES OF WATER. SKIN: WASH W/SOAP &
WATER. INGESTION: INDUCE VOMITING. TREAT SYMTOMATICALLY; NO KNOW
ANTIDOTE. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:NON-FLAMMABLE
================== Accidental Release Measures ==================
Spill Release Procedures:DRUM MAY BE POSITIONED TO ELIMINATE THE LEAK.
SOAK UP SPILLS W/ABSORB-ALL, SCOOP INTO DRUM.
======================Handling and Storage ======================
Handling and Storage Precautions:PRACTICE REASONABLE CARE TO AVOID
CONTACT W/SKIN, EYE & BREATHING VAPORS.
============= Exposure Controls/Personal Protection =============
Ventilation:PROVIDE VENTILATION TO MAINTAIN <TLV.
Other Protective Equipment:CLEAN CLOTHING, COVERALLS
Work Hygienic Practices:PRACTICE REASONABLE CARE TO AVOID CONTACT
W/SKIN & EYES, & BREATHING VAPORS.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:392-580F
Vapor Pres:NIL
Vapor Density:9.4
Spec Gravity:1.730-1.750
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR, COLORLESS LIQUID; MOTHBALL ODOR.
Percent Volatiles by Volume:LOW
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
REDUCING METALS SUCH AS ALUMINUM
Hazardous Decomposition Products:HYDROGEN BROMIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE W/ALL LOCAL, STATE, &
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:YELLOW/GREEN DYE TABLET
CAGE:FO230
CAGE:3D656
CAGE:FO230
============= Composition/Information on Ingredients =============
Ingred Name:NON HAZARDOUS INGREDIENTS
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: DIRECT CONTACT MAY CAUSE
IRRITATION TO THE EYES, SKIN & RESPIRATORY TRACT. INHALATION: MAY
CAUSE IRRITATION IF DUST INHALED. SKIN: MAY BE IRRITATING TO SKIN.
WILL CAUSE STAINING OF SKIN ON CONT ACT. EYES: MAY CAUSE
IRRITATION. INGESTION: URINE MAY HAVE YELLOW/GREEN COLOR UNTIL DYE
HAS BEEN (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: WASHED THROUGH THE SYSTEM. CHRONIC:
NONE KNOWN.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR AT LEAST 15 MIN. GET MED ATTN IF
IRRIT PERSISTS. SKIN: WASH THORO W/SOAP & WATER. GET MED ATTN IF
IRRIT DEVELOPS. INHAL: IF DUST INHALED, MOVE TO FRESH AIR. IF BRTHG
DFCLT, GIV E OXYGEN & GET IMMED MED ATTN. INGEST: DRINK PLENTY OF
WATER & INDUCE VOMIT. GET MED ATTN IF LG QTYS WERE INGESTED/IF NAUS
OCCURS. NEVER GIVE FLUIDS/INDUCE VOMIT IF PERSON UNCON OR HAS
CONVULSIONS.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER FOG, CARBON DIOXIDE OR DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:REMOTE POSSIBILITY OF DUST EXPLOSION. IF
MIXED WITH AIR IN THE PROPER PROPORTIONS, IT CAN BE EXPLOSIVE
(SIMILAR TO FLOUR OR STARCH).
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP SPILLS AND PLACE IN WASTE DISPOSAL
CONTAINER. FLUSH AFFECTED AREA WITH WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE AWAY FROM
EXCESSIVE HEAT OR FLAME.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE A NIOSH/MSHA APPROVED DUST MASK IF DUSTY
CONDITIONS EXIST.
Ventilation:NOT NECESSARY UNDER NORMAL CONDITIONS. USE LOCAL
VENTILATION IF DUSTY CONDITIONS EXIST.
Other Protective Equipment:PROTECTIVE CLOTHING SHOULD BE WORN WHERE
CONTACT IS UNAVOIDABLE. HAVE ACCESS TO AN EMERGENCY EYEWASH.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
SOLUBILITY IN WATER: HIGHLY SOLUBLE WITH A SMALL AMOUNT OF INSOLUBLE
MATERIAL.
================== Physical/Chemical Properties ==================
Spec Gravity:>1
Solubility in Water:SUPDAT
Appearance and Odor:DRY TABLET, ORANGE COLOR WITH NO APPARENT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID BROMINE TRIFLUORIDE, LITHIUM, STRONG ACIDS, BASES AND OXIDIZERS.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:BURNING MAY PRODUCE OXIDES OF CARBON
NITROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE OR REMOVE TO A SUITABLE SOLID WASTE
DISPOSAL SITE. DISPOSE OF ALL WASTES IN ACCORDANCE WITH FEDERAL,
STATE AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:AAM-DEK COLOR FLAKE: HARDENER COMPONENT
Kit Part:Y
Preparer's Name:F. LOELOFF
CAGE:88444
CAGE:88444
============= Composition/Information on Ingredients =============
Ingred Name:MODIFIED CYCLOALIPHATIC POLYAMINE. LD50:(ORAL RAT)>2.37
G/KG.
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:BENZYL ALCOHOL
CAS:100-51-6
RTECS #:DN3150000
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:2,4,6-TRIS(DIMETHYLAMINO METHYL) PHENOL
CAS:90-72-2
RTECS #:SN3500000
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PIPERAZINE, 1-(2-AMONOETHYL)-;(N-AMINOETHYLPIPERAZINE)
CAS:140-31-8
RTECS #:TK8050000
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENT 1.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE:CAUSES IRRITATION AND CHEMICAL
BURNS. SKIN:CAUSES IRRITATION, BURNS, SENSITIZATION AND/OR ALLERGIC
SKIN REACTION WHICH CAN BE SEVERE IN CERTAIN INDIVIDUALS.
INGEST:CAUSES NOSE AND THROAT IRRITATIO N, AND ALLERGIC RESPIRATORY
REACTION. INGEST:WILL CAUSE ESOPHAGEAL DAMAGE IF SWALLOWED.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:ALLERGY, ECZEMA AND OTHER SKIN
CONDITONS.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH WITH LARGE AMOUNTS OF WATER FOR AT LEAST 15
MINUTES. GET MD. SKIN:REMOVE CONTAMINATED CLOTHING AND WASH CONTACT
AREA WITH MILD SOAP & WATER. IF SWELLING OR REDDENING OCCURS, GET
MD. INHAL:MO VE TO FRESH AIR. IF BREATHING HAS STOPPED, ADMINISTER
ARTIFICIAL RESPIRATION. GET MD. INGEST:IF CONSCIOUS GIVE LARGE
AMOUNTS OF WATER OR MILK TO DILUTE. DO NOT INDUCE VOMITING. GET MD.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>200F,>93C
Extinguishing Media:CARBON DIOXIDE, FOAM OR DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:DECOMPOSITION AND COMBUSTION PRODUCTS MAY
BE TOXIC.
================== Accidental Release Measures ==================
Spill Release Procedures:AVOID ALL PERSONAL CONTACT. DIKE SPILL. ABSORB
WITH INERT MATERIAL AND COLLECT FOR DISPOSAL. FLUSH CONTAMINATED
AREA WITH WATER; PREVENT WASHINGS FROM ENTERING WATERWAYS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID ALL PERSONAL CONTACT. DO NOT
EXCEED 110F/43C IN STORAGE AREAS.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR WITH ORGANIC
VAPOR CARTRIDGE IF REQUIRED.
Ventilation:MECHANICAL VENTILATION & LOCAL EXHST ARE REC. MECH EXHST IS
NOT REC AS SOLE MEANS OF CONTROLLING EMPLOYEE EXPOSURE.
Other Protective Equipment:IN OPERS WHERE CONTACT MAY OCCUR COVERALLS,
APRON & IMPERVIOUS FOOT COVERING IS REC. SAFETY SHOWER & EYE WASH
FACILITY.
Work Hygienic Practices:IMMEDIATELY REMOVE AND THOROUGHLY LAUNDER
CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
KEY1:T6.
================== Physical/Chemical Properties ==================
HCC:T6
Boiling Pt:B.P. Text:>200F,>93C
Vapor Pres:<1 @ 68F
Spec Gravity:1.02
Evaporation Rate & Reference:<1 (BUTYL ACETATE=1)
Solubility in Water:PARTLY MISCIBLE
Appearance and Odor:YELLOW LIQUID, AMINE ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:EXCESSIVE HEAT.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE AND
OXIDES OF NITROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL STATE AND
LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:INK CARTRIDGES - ALL COLORS
Preparer's Name:MICHAEL J CHUNKO
CAGE:08987
CAGE:08987
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM SALTS
Fraction by Wt: 1%
Ingred Name:DYE
Fraction by Wt: 1%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Explanation of Carcinogenicity:NONE
======================= First Aid Measures =======================
First Aid:AS REQUIRED
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:NONE
Upper Limits:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP & PLACE IN WASTE DISPOSAL CONTAINER.
FLUSH AREA W/WATER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AS REQUIRED
Ventilation:NONE
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:AS WATER
Vapor Pres:AS WATER
Vapor Density:AS WATER
Spec Gravity:1.1
Evaporation Rate & Reference:AS WATER
Solubility in Water:100%
Appearance and Odor:ODORLESS
Percent Volatiles by Volume:99%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NO SPECIFIC INCOMPATIBILITY
Stability Condition to Avoid:DON'T HEAT UP BEYOND 200F
Hazardous Decomposition Products:ETHYL ALCOHOL & CO2
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:842 9094, KODAK I/S TONER CARTRIDGE
Preparer's Name:NOT PROVIDED
CAGE:19139
CAGE:19139
============= Composition/Information on Ingredients =============
Ingred Name:STYRENE-BUTYL ACRYLATE COPOLYMER
CAS:25767-47-9
Minumum % Wt:85.
Maxumum % Wt:95.
Other REC Limits:NOT PROVIDED
OSHA PEL:NOT PROVIDED
ACGIH TLV:NOT PROVIDED
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Minumum % Wt:5.
Maxumum % Wt:10.
Other REC Limits:NOT PROVIDED
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3
Ingred Name:BIS
(1-(5-(CHLORO-2-HYDROXYPHENYL)AZO)-2-NAPHTHALENOLATO(2-)) HYDROGEN
CHROMATE (1-)
CAS:31714-55-3
Code:F
= Wt:4.
Other REC Limits:NOT PROVIDED
OSHA PEL:NOT PROVIDED
ACGIH TLV:NOT PROVIDED
Ingred Name:SILICA (AMORPHOUS)
CAS:7631-86-9
< Wt:1.
Other REC Limits:NOT PROVIDED
OSHA PEL:NOT PROVIDED
ACGIH TLV:10 MG/M3 (TDUST)
ACGIH STEL:3 MG/M3 (RDUST)
===================== Hazards Identification =====================
LD50 LC50 Mixture:NOT PROVIDED
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EFFECTS OF EXPOSURE: INHALATION:
EXPECTED TO BE A LOW HAZARD FOR RECOMMENDED HANDLING. EYES: NO
SPECIFIC HAZARD KNOWN. MAY CAUSE TRANSIENT IRRITATION. SKIN:
EXPECTED TO BE A LOW HAZARD FOR RECOMMENDE D HANDLING. INGESTION:
EXPECTED TO BE A LOW INGESTION HAZARD. CHRONIC OVEREXPOSURE TO MANY
DUSTS, INCLUDING CARBON BLACK DUST, MAY RESULT IN RESPIRATORY TRACT
IRRITATION AND SLIGHT CHANGES IN LUNG FUN CTION.
Explanation of Carcinogenicity:CARCINOGENICITY CLASSIFICATION
(COMPONENTS PRESENT AT 0.1% OR MORE): - INTERNATIONAL AGENCY FOR
RESEARCH ON CANCER (IARC) (CARBON BLACK): 2B - AMERICAN CONFERENCE
OF GOVERNMENTAL INDUSTRIAL HYGIENISTS (ACGIH): CARBON BLACK, NOT
CLASSIFIABLE AS A HUMAN CARCINOGEN (A4) - NATIONAL TOXICOLOGY
PROGRAM (NTP): NONE - OSHA: NONE.
Effects of Overexposure:EYES: MAY CAUSE TRANSIENT IRRITATION.
Medical Cond Aggravated by Exposure:NOT PROVIDED
======================= First Aid Measures =======================
First Aid:INHALATION: IF SYMPTOMATIC, MOVE TO FRESH AIR. GET MEDICAL
ATTENTION IF SYMPTOMS PERSIST. EYES: ANY MATERIAL THAT CONTACTS
THE EYE SHOULD BE WASHED OUT IMMEDIATELY WITH WATER. GET MEDICAL
ATTENTION I F SYMPTOMS OCCUR. SKIN: WASH WITH SOAP AND WATER. GET
MEDICAL ATTENTION IF SYMPTOMS OCCUR. INGESTION: DRINK 1-2 GLASSES
OF WATER. SEEK MEDICAL ATTENTION. NEVER GIVE ANYTHING BY MOUTH TO
AN UNCONSCIOU S PERSON.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE (CO2), DRY CHEMICAL
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING. FIRE OR EXCESSIVE HEAT MAY PRODUCE HAZARDOUS
DECOMPOSITION PRODUCTS.
Unusual Fire/Explosion Hazard:NONE, BASED ON LIMITED QUANTITY OF
CHEMICAL CONTAINED IN CARTRIDGE. HOWEVER, COMPONENT IS COMBUSTIBLE.
================== Accidental Release Measures ==================
Spill Release Procedures:DO NOT USE A VACUUM CLEANER TO CLEAN UP SPILLS
OF POWDERED TONERS. THE VERY FINE PARTICLES CAN CAUSE A FIRE OR
EXPLOSION. SWEEP MATERIAL ONTO PAPER AND PLACE IN A FIBER CARTON.
AVOID GENERATION OF DUS T. CLEAN SURFACE THOROUGHLY TO REMOVE
RESIDUAL CONTAMINATION.
Neutralizing Agent:NOT RELEVANT
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED. KEEP FROM
CONTACT WITH OXIDIZING MATERIALS.
Other Precautions:AVOID BREATHING DUST. AVOID CONTACT WITH EYES AND
PROLONGED OR REPEATED CONTACT WITH SKIN. USE WITH ADEQUATE
VENTILATION. WASH THOROUGHLY AFTER HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED.
Ventilation:GOOD VENTILATION (TYPICALLY 4-6 ROOM VOLUMES PER HOUR)
SHOULD BE USED. VENTILATION RATES SHOULD BE MATCHED TO CONDITIONS.
Other Protective Equipment:WASHING FACILITIES
Work Hygienic Practices:IT IS A GOOD INDUSTRIAL HYGIENE PRACTICE TO
MINIMIZE EYE CONTACT. IT IS A GOOD INDUSTRIAL HYGIENE PRACTICE TO
MINIMIZE SKIN CONTACT.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:N1
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:NOT RELEVANT
Melt/Freeze Pt:M.P/F.P Text:NOT AVAILABLE
Decomp Temp:Decomp Text:NOT PROVIDED
Vapor Pres:NEGLIGIBLE
Spec Gravity:NOT AVAILABLE
Evaporation Rate & Reference:NEGLIGIBLE
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLACK SOLID (POWDER), SLIGHT ODOR
Percent Volatiles by Volume:NEGLIGIBLE
Corrosion Rate:NOT PROVIDED
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:NOT PROVIDED
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
OXIDES OF NITROGEN, OXIDES OF SULFUR.
=================== Toxicological Information===================
Toxicological Information:IN 1996 THE INTERNATIONAL AGENCY FOR RESEARCH
ON CANCER REEVALUATED CARBON BLACK AS A GROUP 2B CARCINOGEN
(POSSIBLE HUMAN CARCINOGEN), BASED UPON DEVELOPMENT OF LUNG TUMORS
IN RATS RECEIVING CHRONIC I NHALATION EXPOSURES TO FREE CARBON
BLACK. THE EFFECTS WERE OBSERVED ONLY IN ANIMALS EXPOSED TO LEVELS
THAT INDUCE PARTICLE OVERLOAD OF LUNG. STUDIES PERFORMED IN ANIMAL
MODELS OTHER THAN RATS HAVE NOT DEMONSTRATED AN ASSOCIATION
BETWEEN CARBON BLACK AND LUNG TUMORS. MOREOVER, A TWO-YEAR CANCER
BIOASSAY USING TONER PREPARATION CONTAINING CARBON BLACK
DEMONSTRATED NO ASSOCIATION BETWEEN TONER EXPOSU RE AND TUMOR
DEVELOPMENT IN RATS.
===================== Ecological Information =====================
Ecological:IT IS EXPECTED TO HAVE THE FOLLOWING PROPERTIES: A LOW
BIOCHEMICAL OXYGEN DEMAND AND LITTLE POTENTIAL TO CAUSE OXYGEN
DEPLETION IN AQUEOUS SYSTEMS, A MODERATE POTENTIAL TO AFFECT SOME
AQUATIC ORGANISM S, A MODERATE POTENTIAL TO AFFECT THE GROWTH OF
SOME PLANT SEEDLINGS, A MODERATE POTENTIAL TO AFFECT ALGAL GROWTH,
A LOW POTENTIAL TO BIODEGRADE (HIGH PERSISTENCE) WITH UNACCLIMATED
MICROORGANISMS FRO M ACTIVATED SLUDGE, A LOW POTENTIAL TO
BIOCONCENTRATE. AFTER DILUTION WITH A LARGE AMOUNT OF WATER,
FOLLOWED BY SECONDARY WASTE TREATMENT, THIS MATERIAL IS NOT
EXPECTED TO CAUSE ADVERSE ENVIRONMENTAL EFFECTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE OR LANDFILL. CAN BE LANDFILLED WHEN
IN COMPLIANCE WITH LOCAL REGULATIONS. DISCHARGE, TREATMENT, OR
DISPOSAL MAY BE SUBJECT TO NATIONAL, STATE, OR LOCAL LAWS.
=================== MSDS Transport Information ===================
Transport Information:FOR TRANSPORTATION INFORMATION REGARDING THIS
PRODUCT CALL THE KODAK WORLDWIDE TRANSPORTATION HAZMAT HOT LINE:
(716) 722-2400 BETWEEN 8 A.M. AND 5 P.M. (EASTERN STANDARD TIME),
MONDAY THROUGH FRIDAY .
===================== Regulatory Information =====================
SARA Title III Information:CHEMICAL(S) SUBJECT TO THE REPORTING
REQUIREMENTS OF SECTION 313 OR TITLE III OF THE SUPERFUND
AMENDMENTS AND REAUTHORIZATION ACT (SARA) OF 1986 AND 40 CFR PART
372: BIS (1-(5-(CHLORO-2-HYDROXYPH
ENYL)AZO)-2-NAPHTHALENOLATO(2-)) HYDROGEN CHROMATE (1-)
Federal Regulatory Information:NOT PROVIDED
State Regulatory Information:MATERIAL(S) KNOWN TO THE STATE OF
CALIFORNIA TO CAUSE CANCER: NONE - MATERIAL(S) KNOWN TO THE STATE
OF CALIFORNIA TO CAUSE ADVERSE REPRODUCTIVE EFFECTS: NONE
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:BARSOL A-2688
CAGE:FO636
CAGE:FO636
CAGE:0A9L8
============= Composition/Information on Ingredients =============
Ingred Name:SOLVENT NAPHTHA (PETROLEUM) MEDIUM ALIPHATIC
CAS:64742-88-7
Fraction by Wt: >9%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
Ingred Name:TOLUENE (SARA 313) (CERCLA)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 25%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:200 PPM; Z-2
ACGIH TLV:S, 50 PPM; 9596
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA 313) (CERCLA)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 20%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:200 PPM
ACGIH TLV:200 PPM/300STEL;9596
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ETHYL ACETATE (CERCLA)
CAS:141-78-6
RTECS #:AH5425000
Fraction by Wt: >9%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:400 PPM
ACGIH TLV:400 PPM; 9596
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ISOPROPYL ALCOHOL (SARA 313)
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: >9%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:400 PPM
ACGIH TLV:400 PPM/500STEL;9596
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT) IS NOT KNOWN.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYE, SKIN, CNS,
RESPIRATORY & GI TRACTS- MAY CAUSE EYE & SKIN IRRITATION. INGESTION
MAY CAUSE VOMITING; ASPIRATION INTO LUNGS MAY CAUSE LUNG DAMAGE.
INHALATION MAY CAUSE CNS EFFECTS, IRR EGULAR HEARTBEAT, NARCOSIS,
NAUSEA, ASPHYXIATION, EDEMA WHICH MAY BE FATAL. CHRONIC- MAY CAUSE
SLIGHT SKIN SENSITIZATION
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, DRY SKIN, TEARING, BLURRED VISION,
REDNESS, DEFATTING, DERMATITIS, HEADACHE, DIZZINESS, WEAKNESS,
FATIGUE, NAUSEA, VOMITING, DIARRHEA, UNCONSCIOUSNESS, DEATH
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH PRE-EXISTING
DISEASES OF THE EYE, SKIN, RESPIRATORY TRACT, CNS MAY HAVE
INCREASED SUSCEPTIBILITY TO THE TOXICITY OF EXCESSIVE EXPOSURES.
======================= First Aid Measures =======================
First Aid:CALL PHYSICIAN IF SYMPTOMS PERSIST. INHALED:MOVE TO FRESH
AIR. PROVIDE CPR/OXYGEN IF NEEDED. EYES/SKIN:FLUSH WITH WATER FOR
15 MINUTES. HOLD EYELIDS OPEN. ORAL:DO NOT INDUCE VOMITING. IF
PERSON IS DRO WSY/UNCONSCIOUS, PLACE ON LEFT SIDE WITHHEAD DOWN.
GET MEDICAL ATTENTION IMMEDIATELY. IF VOMITING OCCURS, KEEP HEAD
BELOW HIPS TO PREVENT ASPIRATION.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:23.0F,-5.0C
Autoignition Temp:Autoignition Temp Text:750F
Lower Limits:2%
Upper Limits:12%
Extinguishing Media:WATER FOG, FOAM, DRY CHEMICAL/CARBON DIOXIDE. DON'T
USE DIRECT STREAM OF WATER. PRODUCT WILL FLOAT AND CAN BE
REIGNITED.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
NIOSH-APPROVED SELF CONTAINED BREATHING APPARATUS OPERATED IN
POSITIVE PRESSURE MODE. COOL CONTAINER WITH WATER.
Unusual Fire/Explosion Hazard:VAPOR IS HEAVIER THAN AIR AND CAN TRAVEL
CONSIDERABLE DISTANCE TO A SOURCE OF IGNITION AND FLASH BACK.
CONTAINERS MAY RUPTURE DUE TO VAPOR PRESSURE BUILDUP.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. ELIMINATE SOURCES
OF IGNITION. VENTILATE AREA. REMOVE SPILL WITH NON-FLAMMABLE
ABSORBENT SUCH AS SAND/CLAY. PLACE IN CONTAINER FOR DISPOSAL. WASH
SPILL SITE AFTER PICK UP IS COMPLETE. PREVENT LIQUID FROM
ENTERINGSEWERS.
Neutralizing Agent:NOT RELEVANT
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN TIGHTLY CLOSED CONTAINERS IN
VENTILATED AREA AWAY FROM IGNITION SOURCES & INCOMPATIBLES. KEEP
OUT OF REACH OF CHILDREN.
Other Precautions:FLAMMABLE. "EMPTY" CONTAINERS RETAIN RESIDUE AND CAN
BE DANGEROUS. DO NOT PRESSURIZE, CUT, WELD, BRAZE, SOLDER OR DRILL.
AVOID BREATHING VAPORS. DO NOT GET IN EYE, ON SKIN OR ON CLOTHING.
AVOID DIRECT SUN. DO NOT INGEST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF TLV IS EXCEEDED OR FOR SYMPTOMS OF OVER
EXPOSURE, WEAR NIOSH-APPROVED ORGANIC VAPOR RESPIRATOR OR
AIR-SUPPLIED RESPIRATOR. IN EMERGENCY, WEAR A NIOSH-APPROVED
POSITIVE-PRESSURE SELF-CONTAINED BREAT HING APPARATUS.
Ventilation:MECHANICAL (GENERAL AND/OR LOCAL EXHAUST, EXPLOSION-PROOF)
VENTILATION TO MAINTAIN EXPOSURE BELOW TLV(S).
Other Protective Equipment:EYE WASH STATION & SAFETY SHOWERS SHOULD BE
AVAILABLE IN THE IMMEDIATE VICINITY OF ANY POTENTIAL EXPOSURE. LAB
COAT
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. WASH AFTER HANDLING AND BEFORE EATING OR
DRINKING.
Supplemental Safety and Health
FORMULA CHANGED. FOR PREVIOUS FORMULATIONS, SEE PNI A AND B, SAME NSN.
================== Physical/Chemical Properties ==================
HCC:F2
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:171F,77C
Melt/Freeze Pt:M.P/F.P Text:-119F,-84C
Vapor Pres:73 @ 68F
Vapor Density:4.7
Spec Gravity:0.83
Evaporation Rate & Reference:3.8 (N-BUTYL ACETATE=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:CLEAR LIQUID - HYDROCARBON ODOR
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, ACIDS, ALKALIS, REDUCING AGENTS, METALS,
ORGANIC MATERIALS, HALOGENS
Stability Condition to Avoid:HIGH HEAT, SPARKS, OPEN FLAMES, HOT METAL
SURFACES AND OTHER SOURCES OF IGNITION, MOISTURE
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. RECYCLING, INCINERATION OR REUSING IS
RECOMMENDED.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:INVOLL-30, 054XX
Preparer's Name:MARC C TARPLEE
CAGE:59256
CAGE:59256
============= Composition/Information on Ingredients =============
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATES, HYDROTREATED HEAVY
PARAFFINIC. LIMITS AS OIL MIST.
CAS:64742-54-7
RTECS #:PY8035500
Fraction by Wt: 100%
OSHA PEL:5 MG/M3
ACGIH TLV:5MG/M3;10MG/M3 STEL
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:EXPOSURE TO OILS MISTS MAY CAUSE
NAUSEA AND EYE IRRITATION. DETAILED STUDIES HAVE NOT BEEN MADE, BUT
MATERIAL IS NOT EXPECTED TO BE DERMATITIC OR A SENSITIZER.
CHRONIC:UNKNOWN.
Explanation of Carcinogenicity:MINERAL OILS:CAS NO. 64742-54-7 IS
LISTED BY THE RTECS AS AN IARC GROUP 1 CARCINOGEN.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:SKIN:WASH WITH SOAP AND WATER. EYES:FLUSH WITH WATER FOR AT
LEAST 15 MINUTES. CONTACT MD. INGEST:GIVE LIQUID AND INDUCE
VOMITING IF VICTIM IS CONSCIOUS. CONTACT MD. SMALL AMOUNTS IN MOUTH
MAY BE WASHE D OUT. INHAL:REMOVE TO FRESH AIR. SUPPORT BREATHING
(GIVE O2/ ARTIFICIAL RESPIRATION) .
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:>415F,>213C
Extinguishing Media:WATER FOG, CHEMICAL FOAM OR CARBON DIOXIDE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL PROT
EQUIP WHEN FIGHTING FIRES IN ENCLOSES SPACES. INCOMPLETE COMBUST
OF THIS MATL PRODUCES CARBON MONOXIDE!
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL SPILLS MAY BE WIPED UP WITH A RAG. LARGE
SPILLS SHOULD BE PICKED UP IMMEDIATELY WITH AN ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE
Other Precautions:NFPA CLASS III B MATERIAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:US GOV'T 8 HR TWA LIM FOR EXPOS TO OIL MISTS IS 5 MG PER
CUBIC METER. LOC/MECHANICAL EXHAUST:AS REQUIRED TO MEET LIMIT.
Other Protective Equipment:NONE SHOULD BE REQUIRED UNDER NORMAL USE.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:T6
Boiling Pt:B.P. Text:>392F,>200C
Vapor Pres:<0.001TORR
Vapor Density:APPROX 14
Spec Gravity:0.86
Evaporation Rate & Reference:NIL (ETHER = 1)
Solubility in Water:NIL
Appearance and Odor:PALE YELLOW, VISCOUS LIQUID WITH FAINT PETROLEUM
ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:CONTINUOUS EXPOSURE TO TEMPERATURES >
200C.
Hazardous Decomposition Products:INCOMPLETE COMBUSTION MAY PRODUCE CO.
==================== Disposal Considerations ====================
Waste Disposal Methods:PROPER WASTE DISPOSAL PROCEDURES ARE DEPENDENT
ON THE PRODUCTS END-USE. CHECK APPLICABLE FEDERAL, STATE AND LOCAL
REGULATIONS COVERING TREATMENT, STORAGE AND DISPOSAL OF YOUR
PROCESS EFFLUENTS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:83-8-104412 RP900 BLACK RUBBER BASE INK 5 LBS
CAGE:FO004
CAGE:FO004
CAGE:09177
============= Composition/Information on Ingredients =============
Ingred Name:WHITE MINERAL OIL
CAS:8042-47-5
RTECS #:PY8047000
Fraction by Wt: 30-35%
Other REC Limits:STEL 10 MG/CUM
OSHA PEL:5 MG/CUM MIST
ACGIH TLV:5 MG/CUM MIST
Ingred Name:MODIFIED ROSIN ESTERS
Fraction by Wt: 25-30%
Ingred Name:HYDROCARBON RESIN
Fraction by Wt: 10-15%
Ingred Name:PIGMENT
Fraction by Wt: 13-15%
Ingred Name:LINSEED OIL
Fraction by Wt: 5-10%
Ingred Name:POLYETHYLENE WAX
Fraction by Wt: 2-3%
Ingred Name:VOLATILE ORGANIC CONTENT: 0.42 LBS/GAL; (51 GM/L)
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: MAY CAUSE BURNING & IRRITATION.
SKIN: PROLONGED/REPEATED EXPOSURE CAUSES IRRITATION/DERMATITIS.
INGESTION: MAY CAUSE IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:BURNING, IRRITATION, HEADACHE, DIZZINESS,
DROWSINESS, NAUSEA, GASTRIC DISTURBANCE
Medical Cond Aggravated by Exposure:SOME SKIN DISORDERS SUCH AS
DERMATITIS.
======================= First Aid Measures =======================
First Aid:EYES: RINSE THOROUGHLY W/WATER FOR 15 MINS. SKIN: WASH W/MILD
SOAP & WATER. INHALATION: REMOVE TO FRESH AIR. GIVE CPR/OXYGEN IF
NECESSARY. INGESTION: DON'T INDUCE VOMITING. OBTAIN MEDICAL
ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:245F
Extinguishing Media:FOAM, CO2, DRY CHEMICAL
Fire Fighting Procedures:WATER CAN BE USED TO KEEP MATERIAL COOL. USE
SELF CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:DENSE SMOKE MAY BE GENERATED WHILE
BURNING.
================== Accidental Release Measures ==================
Spill Release Procedures:WIPE UP W/RAGS. DISPOSE OF RAGS IN CONTAINERS
APPROVED FOR OILY WASTE.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS CLOSED WHEN NOT IN
USE. KEEP AWAY FROM EXCESSIVE HEAT, SPARKS & OPEN FLAME. DON'T
REUSE CONTAINER. FOR COMMERCIAL/INDUSTRIAL USE ONLY.
Other Precautions:KEEP FROM REACH OF CHILDREN. PREVENT EXCESSIVE SKIN
CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NORMALLY REQUIRED
Ventilation:GENERAL VENTILATION
Other Protective Equipment:APRON, BOOTS, IMPERVIOUS CLOTHING
Work Hygienic Practices:WASH HANDS & FACE W/SOAP & WATER BEFORE
EAING/SMOKING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>200F
Vapor Pres:0.1 @ 70F
Vapor Density:>1
Spec Gravity:>1
Evaporation Rate & Reference:SLOWER THAN BU ACETATE
Solubility in Water:INSOLUBLE
Appearance and Odor:COLORED PASTE W/OILY ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:EXCESS HEAT, SPARKS & OPEN FLAME
Hazardous Decomposition Products:WHEN BURNING: DENSE SMOKE, CO, CO2
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATION IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CONGO RED, S71402
CAGE:1B464
CAGE:1B464
============= Composition/Information on Ingredients =============
Ingred Name:C.I. DIRECT RED 28. LD50:(ORAL,RAT) 15,200 MG/KG.
EINECS/ELINCS: 209-358-4.
CAS:573-58-0
RTECS #:QK1400000
= Wt:100.
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENT.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYE: MAY CAUSE IRRITATION.
SKIN: MAY CAUSE IRRITATION. MAY CAUSE SENSITIZATION, AN ALLERGIC
REACTION, WHICH BECOMES EVIDENT UPON RE-EXPOSURE TO THIS MATERIAL.
INGESTION: MAY CAUSE GASTROINTESTI NAL IRRITATION WITH NAUSEA,
VOMITING AND DIARRHEA. LOW HAZARD FOR USUAL INDUSTRIAL HANDLING.
INHALATION: MAY CAUSE RESPIRATORY TRACT IRRITATION. LOW HAZARD FOR
USUAL INDUSTRIAL HANDLING. CHRONIC: MAY CAUSE REPRODUCTIVE AND
FETAL EFFECTS. WARNING! THIS SUBSTANCE HAS CAUSED ADVERSE
REPRODUCTIVE AND FETAL EFFECTS IN ANIMALS. TARGET ORGANS: NONE.
Explanation of Carcinogenicity:NOT LISTED BY ACGIH, IARC, NIOSH, NTP OR
OSHA.
Effects of Overexposure:SEE HEALTH HAZARDS.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES,
OCCASIONALLY LIFTING UPPER & LOWER LIDS. GET MEDICAL AID. SKIN: GET
MEDICAL AID. WASH CLOTHING BEFORE REUSE. FLUSH SKIN WITH PLENTY OF
SOAP & WATER. DESTROY CONTAMINATED SHOES. INGESTION: IF VICTIM IS
CONSCIOUS & ALERT, GIVE 2-4 CUPFULS OF MILK OR WATER. NEVER GIVE
ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. GET MEDICAL AID.
INHALATION: REM OVE FROM EXPOSURE TO FRESH AIR IMMEDIATELY. IF NOT
BREATHING, GIVE ARTIFICIAL RESPIRATION. IF BREATHING IS DIFFICULT,
GIVE OXYGEN. GET MEDICAL AID. NOTES TO MD: TREAT SYMPTOMATICALLY &
SUPPORTIVELY.
===================== Fire Fighting Measures =====================
Lower Limits:NOT AVAIL
Upper Limits:NOT AVAIL
Extinguishing Media:USE EXTINGUISHING MEDIA MOST APPROPRIATE FOR THE
SURROUNDING FIRE. IN CASE OF FIRE USE WATER SPRAY, DRY CHEMICAL,
CARBON DIOXIDE OR APPROPRIATE FOAM.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:DURING A FIRE, IRRITATING & HIGHLY TOX
GASES MAY BE GENERATED BY THERMAL DECOMP/COMBUST. THIS MATL IN
SUFFICIENT QTY & REDUCED PARTICLE SIZE IS CAPABLE OF CREATING A
DUST EXPLO. VAPS MAY BE HVR/AIR. T HEY CAN SPREAD ALONG GROUND &
COLLECT IN LOW/CONFINED AREAS. HEALTH - 2; FLAMMABILITY - 0;
REACTIVITY - 0.
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTIVE EQUIPMENT AS
INDICATED IN EXPOSURE CONTROLS, PERSONAL PROTECTION SECTION. CLEAN
UP SPILLS IMMEDIATELY, OBSERVING PRECAUTIONS IN THE PROTECTIVE
EQUIPMENT SECTION. SWEEP U P OR ABSORB MATERIAL, THEN PLACE INTO A
SUITABLE CLEAN, DRY, CLOSED CONTAINER FOR DISPOSAL. AVOID
GENERATING DUSTY CONDITIONS. PROVIDE VENTILATION.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT AND FLAME. STORE
IN A COOL, DRY PLACE. KEEP CONTAINERS TIGHTLY CLOSED.
Other Precautions:USE WITH ADEQUATE VENTILATION. MAY FORM FLAMMABLE
DUST/AIR MIXTURES. KEEP CONTAINER TIGHTLY CLOSED. DO NOT GET ON
SKIN OR IN EYES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:A NIOSH APPROVED RESPIRATORY PROGRAM THAT MEETS
OSHA'S 29 CFR '1910.134 AND ANSI Z88.2 REQUIREMENTS OR EUROPEAN
STANDARD EN 149 MUST BE FOLLOWED WHENEVER WORKPLACE CONDITIONS
WARRANT A RESPIRATOR'S US E.
Ventilation:USE ADEQUATE VENTILATION TO KEEP AIRBORNE CONCENTRATIONS
LOW.
FACESHIELD .
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
WEAR APPROPRIATE PROTECTIVE CLOTHING TO PREVENT SKIN EXPOSURE.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. REMOVE
CONTAMINATED CLOTHING AND WASH BEFORE REUSE. WASH CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
PHYSICAL AND CHEMICAL PROPERTIES: DENSITY: NOT AVAILABLE. MOLECULAR
FORMULA: C32H22N6O6S2NA2. MOLECULAR WEIGHT: N/P.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:NOT AVAILABLE
Melt/Freeze Pt:=360.C, 680.F
Decomp Temp:Decomp Text:NOT AVAILABLE
Vapor Pres:NEGLIGIBLE
Vapor Density:24.1
Spec Gravity:NOT AVAILABLE
pH:8-9.5
Viscosity:NOT AVAILABLE
Solubility in Water:SLIGHTLY SOLUBLE
Appearance and Odor:DARK RED-BROWN SOLID; ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS CAN CAUSE FIRE OR EXPLOSION ON CONTACT.
INCOMPATIBLE WITH STRONG REDUCING AGENTS, STRONG ACIDS.
Stability Condition to Avoid:STABLE AT ROOM TEMP IN CLSD CNTNRS UNDER
NORMAL STORAGE & HNDLG CNDTNS. MATLS CONTAINING SIMILAR FUNCTIONAL
GRPS CAN DECOMPOSE AT ELEVATED TEMPS. AVOID INCOMPAT MATLS, EXCESS
HEAT.
Hazardous Decomposition Products:CARBON MONOXIDE, OXIDES OF SULFUR,
CARBON DIOXIDE, NITRIC OXIDES (NO*X), AND AMMONIA (NH3) FUMES,
NITROGEN.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
=================== Toxicological Information===================
Toxicological Information:CAS # 573-58-0: RTECS # QK1400000:
EPIDEMIOLOGY: NO DATA AVAIL FROM IARC, NTP/OSHA REGARDING CARCIN OF
CONGO RED. HOWEVER, CONGO RED IS A BENZIDINE-BASED DYE & BENZIDINE
HAS BEEN CLASSIFIED BY IARC AS GRP 1 CARCINS. TERATOGENICITY:
DEVELOPMENTAL ABNORMS IN CNS & UROGENITAL SYSTEMS & IN THE EYE &
EAR HAVE BEEN REPORTED IN TESTS W/LAB ANIMALS. REPRO EFTS:
REDUCTIONS OF FEMALE FERTILITY INDEX, PATERN AL EFTS & FETOTOXICITY
HAVE BEEN REPORTED IN TESTS W/LAB ANIMALS. NEUROTOXICITY: NO INFO
AVAIL. MUTAGENICITY: MUTAGENICITY STUDIES HAVE BEEN PERFORMED USING
MICROORGANISMS & LAB ANIMALS. OTHER STUDIES : NO DATA AVAILABLE.
===================== Ecological Information =====================
Ecological:ECOTOXICITY: NOT AVAILABLE. ENVIRONMENTAL FATE: DOES NOT
BIOCONCENTRATE, LOW BIODEGRADATION POTENTIAL. PHYSICAL/CHEMICAL:
NOT AVAILABLE. OTHER: NOT AVAILABLE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN A MANNER CONSISTENT WITH FEDERAL,
STATE AND LOCAL REGULATIONS. RCRA: D-SERIES MAXIMUM CONCENTRATION
OF CONTAMANTS; D-SERIES CHRONIC TOXICITY REFERENCE LEVELS;
F-SERIES; P-SERIES; & U-SER IES: NONE LISTED.
=================== MSDS Transport Information ===================
Transport Information:U.S. DOT: SHIPPING NAME: NO INFORMATION
AVAILABLE. IATA: SHIPPING NAME: NO INFORMATION AVAILABLE. RID/ADR:
SHIPPING NAME: NO INFORMATION AVAILABLE. IMO: SHIPPING NAME: NO
INFORMATION AVAILABLE. CANADA TDG: SHIPPING NAME: NO INFORMATION
AVAILABLE.
===================== Regulatory Information =====================
SARA Title III Information:SECTION 302 (RQ): NONE OF THE CHEMICALS IN
THIS MATERIAL HAVE AN RQ. SECTION 302 (TPQ): NONE OF THE CHEMICALS
IN THIS PRODUCT HAVE A TPQ. SARA CODES: CAS # 573-58-0: CHRONIC.
SECTION 313: NO CHEMICALS ARE REPORTABLE UNDER SECTION 313.
Federal Regulatory Information:TSCA: CAS # 573-58-0 IS LISTED ON TSCA
INVENTORY. HEALTH & SAFETY REPORTING LIST: NONE OF THE CHEMS ARE ON
HEALTH & SAFETY REPORTING LIST. CHEM TEST RULES: NONE OF THE CHEMS
IN THIS PROD ARE UNDER A C HEM TEST RULE. SECTION 12B: CAS #
573-58-0: EXPORT NOTIFICATION REQD; C.I. 22120. TSCA SIGNIFICANT
NEW USE RULE: CAS # 573-58-0 IS A CHEM W/SIGNIFICANT NEW USE RULE.
CLEAN AIR ACT: THIS MATL DOES NOT CONTAIN ANY HAZ AIR POLLUTANTS.
THIS MATL DOES NOT CONTAIN ANY CLASS 1 OZONE DEPLETORS. THIS MATL
DO ES NOT CONTAIN ANY CLASS 2 OZONE DEPLETORS. CLEAN WATER ACT:
NONE OF THE CHEMS IN THIS PROD ARE LISTED AS HAZ (STATE REGULATORY
INFO)
State Regulatory Information:CAS # 573-58-0 CAN BE FOUND ON THE
FOLLOWING STATE RIGHT TO KNOW LISTS: NEW JERSEY. CALIFORNIA NO
SIGNIFICANT RISK LEVEL: NONE OF THE CHEMS IN THIS PROD ARE LISTED.
-- FEDERAL REGULATORY: SUBSTANCES U NDER THE CWA. NONE OF THE CHEMS
IN THIS PROD ARE LISTED AS PRIORITY POLLUTANTS UNDER THE CWA. NONE
OF THE CHEMS IN THIS PROD ARE LISTED AS TOXIC POLLUTANTS UNDER THE
CWA. OSHA: NONE OF THE CHEMS IN TH IS PROD ARE CONSIDERED HIGHLY
HAZ BY OSHA. EUROPEAN/INTERNATIONAL REGS: EUROPEAN LABELING I/A/W
EC D IRECTIVES: HAZ SYMBOLS: NOT AVAIL. RISK PHRASES:N/P. SAFETY
PHRASES: N/P. WGK (WATER DANGER/PROT): CAS # 573-58-0: 1. CANADA:
(OTHER INFO)
======================= Other Information =======================
| 1 | gloves_mandatory |
=======================================================
Product ID: N10004 ALLOY W
Cage: FO782
Box: 9013
=======================================================
Preparer Co. when other than Responsible Party Co.
=======================================================
Cage: FO782
Assigned Ind: Y
Box: 9013
=======================================================
Contractor Summary
=======================================================
Cage: 80357
Box: 9013
Cage: FO782
Box: 9013
=======================================================
Ingredients
=======================================================
Cas: 7439-98-7
RTECS #: QA4680000
% Wt: 24
OSHA PEL: 5 MG/CUM
ACGIH TLV: 5 MG/CUM
------------------------------
Cas: 7440-02-0
RTECS #: QR5950000
CARCINOGEN BY NTP) *96-2*
% Wt: 63
Other REC Limits: 1 MG/CUM
OSHA PEL: 1 MG/CUM
ACGIH TLV: 0.05 MG/CUM IC
-----------------------------
Cas: 7440-21-3
RTECS #: VW0400000
% Wt: <1
ACGIH TLV: 10 MG/CUM
------------------------------
Cas: 7440-62-2
RTECS #: YW1355000
% Wt: <0.6
Other REC Limits: 0.1 MG/CUM
OSHA PEL: 0.05 MG/CUM
ACGIH TLV: 0.05 MG/CUM
------------------------------
Cas: 7440-48-4
RTECS #: GF8750000
% Wt: <2.5
Other REC Limits: 0.05 PPM
OSHA PEL: 0.1 MG/CUM
ACGIH TLV: 0.05 MG/CUM
-----------------------------
Cas: 7440-47-3
RTECS #: GB4200000
GROUP 3) *96-2*
% Wt: 5
ACGIH TLV: 0.5 MG/CUM
EPA Rpt Qty: 1 LB
DOT Rpt Qty: 1 LB
------------------------------
Cas: 7439-89-6
RTECS #: NO4565500
% Wt: 6
------------------------------
Cas: 7439-96-5
RTECS #: OO9275000
% Wt: <1
OSHA PEL: 5 MG/CUM
ACGIH TLV: 5 MG/CUM (DUST)
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: YES
IARC: YES
OSHA: NO
Effects of Exposure: SHORT TERM EXPOSURE TO WELDING FUMES: DIZZINESS, NAUSEA,
DRYNESS/IRRITATION OF NOSE/THROAT/LUNGS/EYES. LONG TERM EXPOSURE TO WELDING
FUMES: RESPIRATORY PROBLEMS, IRON BUILD-UP IN THE LUNGS, BONE EROSI ON,
REDUCED PULMONARY FUNCTIONS & NERVOUS DISORDERS.
Explanation Of Carcinogenicity: SEE INGREDIENTS
Signs And Symptions Of Overexposure: SHORT TERM EXPOSURE TO WELDING FUMES:
DIZZINESS, NAUSEA, DRYNESS, IRRITATION OF NOSE/THROAT/LUNGS/EYES. LONG TERM
EXPOSURE TO WELDING FUMES: RESPIRATORY PROBLEMS, IRON BUILD UP IN THE LUNGS,
BONE EROS ION, REDUCED PULMONARY FUNCTIONS & NERVOUS DISORDERS.
Medical Cond Aggravated By Exposure: PRE-EXISTING RESPIRATORY/ALLERGIC
CONDITIONS.
First Aid: INHALATION: REMOVE TO FRESH AIR. GIVE CPR IF NEEDED. INGESTION: GIVE
WATER & INDUCE VOMITING IF CONSCIOUS. SKIN: CUTS & ABRASIONS CAN BE
TREATED BY STANDARD FIRST AID. CONTAMINATION W/DUST/POWDER CAN BE REMOVED BY
WASHING W/SOAP & WATER. EYES: FLUSH W/COPIOUS AMOUNTS OF CLEAN WATER.
OBTAIN MEDICAL ATTENTION IN ALL CASES.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: SOLIDS: NO SPECIAL CLEAN UP PROBLEMS. POWDER/DUST
FORM: CLEAN UP W/VACUUM SYSTEM UTILIZING A HIGH EFFICIENCY PARTICULATE AIR
FILTRATION SYSTEM. USE CAUTION TO MINIMIZE AIRBORNE GENERATION OF POWDER/DU
ST & AVOID CONTAMINATION OF AIR & WATER.
Waste Disposal Methods: DISPOSE OF IAW/FEDERAL, STATE & LOCAL REGULATIONS.
Handling And Storage Precautions: PRODUCT MUST BE HANDLED ACCORDING TO SIZE,
SHAPE & QUANTITY INVOLVED. SOLID METAL MAY REQUIRE USE OF HOISTS, CRANES.
Other Precautions: POWDERS SHOULD BE MOVED/TRANSPORTED TO MINIMIZE
SPILL/RELEASE POTENTIAL.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: NONE
Lower Limits: NONE
Upper Limits: NONE
Extinguishing Media: USE MEDIA APPROPRIATE FOR SURROUNDING AREAS.
Fire Fighting Procedures: IF MATERIALS ARE REDUCED TO POWDER FORM, USE CAUTION.
TO EXTINGUISH A METAL POWDER FIRE USE DRY SAND, DRY GRAPHITE/OTHER CLASS D
EXTINGUISHING POWDER.
=======================================================
Control Measures
=======================================================
Respiratory Protection: USE NIOSH APPROVED RESPIRATORS. USE A FUME
RESPIRATOR/AIR SUPPLIED RESPIRATOR WHERE LOCAL EXHAUST/VENTILATION DOESN'T
KEEP EXPOSURE BELOW THE OSHA LIMITS FOR AIR CONTAMINATION.
Ventilation: LOCAL EXHAUST VENTILATION
Other Protective Equipment: UNIFORMS, DISPOSABLE COVERALLS, SAFETY SHOES.
Supplemental Safety and Health: SPILLS CONT'D: PROPERLY LABEL ALL MATERIALS
COLLECTED IN WASTE CONTAINER.
=======================================================
Physical/Chemical Properties
=======================================================
M.P/F.P Text: 2400F
Solubility in Water: NONE
Appearance and Odor: SOLID-SILVER GRAY COLOR-NO COLOR
Percent Volatiles by Volume: NONE
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Materials To Avoid: MINERAL ACIDS, OXIDIZING AGENTS
Hazardous Decomposition Products: HYDROGEN GAS
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: N10004 ALLOY W
Cage: FO782
Assigned IND: Y
Company Name: HAYNES INTL INC SUB OF CABOT CORP
Street: 1020 W PARK AVE
PO Box: 9013
Zipcode: 46904-9013
Label Required IND: Y
Date Of Label Review: 12/16/1998
Status Code: C
Label Date: 12/16/1998
Origination Code: G
Hazard And Precautions: SHORT TERM EXPOSURE TO WELDING FUMES: DIZZINESS,
NAUSEA, DRYNESS/IRRITATION OF NOSE/THROAT/LUNGS/EYES. LONG TERM EXPOSURE TO
WELDING FUMES: RESPIRATORY PROBLEMS, IRON BUILD-UP IN THE LUNGS, BONE EROSI
ON, REDUCED PULMONARY FUNCTIONS & NERVOUS DISORDERS.
SHORT TERM EXPOSURE TO WELDING
FUMES: DIZZINESS, NAUSEA, DRYNESS, IRRITATION OF NOSE/THROAT/LUNGS/EYES.
LONG TERM EXPOSURE TO WELDING FUMES: RESPIRATORY PROBLEMS, IRON BUILD UP IN
THE LUNGS, BONE EROSION, REDUCED PULMONARY FUNCTIONS & NERVOUS DISORDERS.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:RHODORSIL FLUID 47V20
CAGE:41629
CAGE:41629
CAGE:7B998
CAGE:2B613
============= Composition/Information on Ingredients =============
Ingred Name:POLY (DIMETHYLSILOXANE)
CAS:63148-62-9
RTECS #:JJ6484500
Fraction by Wt: NP
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 RATS,ORAL >5004MGKG
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE:SLIGHTLY IRRIT,MAY CAUSE
REDNESS,IRRIT.SKIN:NON-RIRIT.INHAL:NOT LIKELY.INGEST:PRACTICALLY
NON-TOXIC.CHRONIC:DOESNT CONTAN ANY INGRED DESIGNATED BY
IARC/NTP/ACGIH/OSHA AS PROBABLE/SUSPECTED HUMAN C ARCINOGENS.
Explanation of Carcinogenicity:PER MSDS:DOESNT CONTAIN ANY INGRED
DESIGNATED BY IARC/NTP/ACGIH/OSHA AS PROBABLE/SUSPECTED HUMAN
CARCINOGENS.
Effects of Overexposure:IRRIT EYE, REDNESS.
Medical Cond Aggravated by Exposure:NO SPECIFIC INFORMATION FOUND.
======================= First Aid Measures =======================
First Aid:EYE:IMMED ABSORB EXCESS W/CLEAN ABSORBENT CLOTH/COTTON.OPEN
EYELIDS,FLUSH W/STEADY GENTLY H2O STREAM FOR @LEAST 15MINS.IRRIT
DVLP/PERSIST/VISUAL CHANGES OCCUR SEEK MED ATTN.SKIN:IMMED WIPE
EXCESS W/DR Y CLOTH.WASH W/PLENTY OF SOAP/H2O.IRRITDVLP/PERSIST
SEEK MED ATTN.INHAL:NOT EXPECTED ROUTE OF EXPO.RESP IRRIT/DISTRESS
OCCUR REMOVE TO FRESH AIR;CONTS SEEK MED ATTN.INGEST:CONS/ALERT
GIVE 1-2(SUPPLE)
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:>446F,>230C
Autoignition Temp:Autoignition Temp Text:NP
Lower Limits:NO DATA
Upper Limits:NO DATA
Extinguishing Media:RECOMMENDED:DRY CHEMICAL, FOAM, CARBON DIOXIDE.
Fire Fighting Procedures:FIREFIGHTERS SHOULD WEAR NIOSH/MSHA APPROVED
SELF-CONTAINED BREATHING APPARATUS & FULL PROTECTIVE CLOTHING.COOL
CNTNR EXPO TO FIRE W/WATER.
Unusual Fire/Explosion Hazard:PRODUCT WILL BURN UNDER FIRE CONDITIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR APPROPR PROT GEAR FOR SITUATION.SEE PPE
SECTION.CAUTION:SPILLED MATL MAY MAKE FLOOR SLIPPERY.DONT LEAVE
TRACES OF PRODUCT ON FLOORS/LADDERS/ETC AS THIS MAY PRESENT
SLIPPING HAZ.ABSORB W/INERT ABS ORBENT.SCRAPEUP/PLACE IN CLSD
CNTNR.CLEANUP(NEUTR)
Neutralizing Agent:SPILL:W/APPROPR SOLVT(PAINT THINNER/MINERAL
SPIRITS)-GOOD VENTI/NO IGN SOURCES.
======================Handling and Storage ======================
Handling and Storage Precautions:>25C(77F) STORAGE TEMPS.AVOID VAP/MIST
BREATH.AVOID DIRECT/PROL CONTACT W/SKIN/EYES.USE NONSPARK
TOOLS/GROUND/BOND EQPMT/CNTNR WHEN TRANSFERRING.
Other Precautions:CONTAINS DIMETHYLPOLYSILOXANE CAN GENERATE
FORMALDEHYDE AS BYPRODUCT OF OXIDATIVE THERM DECOMPO BEGINNING
@APPROX 150C(300F).FORMALDEHYDE EXPO-CAUSE ADVERSE
EFFECTS-SKIN/RESP SENS,EYE/THROAT IRRIT,POT CANC
HAZ.EVALUATE/CNTRL EXPO(SUP)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHEN RESP REQUIRED SELECT NIOSH/MSHA APPROV
EQPMT BASED ON ACTUAL/POT AIRBORNE CONC & IAW APPROP REG STD &/OR
INDUSTRIAL RECOMMENDATIONS.FOR REASONABLY FORESEEABLE INDUSTRIAL
END USEDS OF MATL RESP PR OT SHOULDNT BE NECESSARY.
Ventilation:NONE SPECIFIED BY MANUFACTURER.
CLOTH(SHIRTS,PANTS).CONSIDER DURABILITY/PERMEATION RESISTANCE.
Work Hygienic Practices:GOOD INDUSTRIAL HYG PRAC SHOULD BE USED IN
HNDLG MATL.STORE IN TIGHT CLSD CNTNR-EPOXY-COAT
STEEL,PLAS,POLYETHYLENE.
Supplemental Safety and Health
OTHER PRECA:TO FORMALDEHYDE WHEN WARRANTED BY USE CONDITIONS.
1STAID:GLASSES OF H2O TO DRINK.DONT GIVE ANYTHING BY MOUTH IF
UNCONSC.GET MED ATTN.DONT LEAVE UNATTN.DR:ALL TREAT SHOULD BE BAESD
ON OBSER VE SIGNS/SYMPT OF DISTRSS IN PATIENT.CONSIDERATION SHOULD
BE GIVEN TO POSSIBLITY MATL OVEREXPO OTHER THAN PROD MAY OCCUR
================== Physical/Chemical Properties ==================
HCC:V6
Boiling Pt:B.P. Text:N/AVAI
Melt/Freeze Pt:M.P/F.P Text:N/AVAI
Decomp Temp:Decomp Text:NP
Vapor Pres:<0.01@200C
Vapor Density:N/AVAI
Spec Gravity:0.95 @25C
pH:N/APPL
Viscosity:20CS @25C
Evaporation Rate & Reference:NP
Solubility in Water:INSOLUBLE
Appearance and Odor:CLEAR VISCOUS LIQUID, ODORLESS
Percent Volatiles by Volume:NP
Corrosion Rate:NP
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG BASES,STRONG ACIDS,STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HEAT,OPEN FLAME,SPARK,STATIC ELECTRICITY
Hazardous Decomposition Products:FORMALDEHYDE,OXIDES OF
CARBON,SILICA(CRYSTALLINE).THERM-DIMETHYLCYCLOSILOXANES,METHYLPHENY
LCYCLOSILOXANES;OXI/THER-FORMA
==================== Disposal Considerations ====================
Waste Disposal Methods:DONT FLUSH SPILL TO DRAIN.CHEM
ADDN/PROCESS/OTHERWISE ALTER MATL MAY MAKE WSTE MNGMT INFO IN MSDS
INCOMPL/INACCU/INAPPRO.BE ADVISED STATE/LOC REQMTS FOR WSTE DISPO
MAY BE MORE RESTRICTIVE/DIFF FROM FE D LAW/REG.CONSULT STATE/LOC
REGS.EMPTY-DECONTAM
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:CC-100: AGGREGATE COMPONENT
Preparer's Name:F. LOELOFF
CAGE:AMSAT
CAGE:88444
CAGE:AMSAT
============= Composition/Information on Ingredients =============
Ingred Name:PIGMENTED VINYL POLYMER FLAKE
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES:PARTICLES MAY CAUSE TRANSIENT EYE
IRRITATION. SKIN/INGESTION:NOT APPLICABLE. INHALATION:NO
STATISTICAL SIGNS OR EVIDENCE THAT ACUTE OR CHRONIC HEALTH EFFECTS
MAY OCCUR IN EXPOSED EMPLOYEES.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NOT ESTABLISHED.
======================= First Aid Measures =======================
First Aid:INGESTION:CALL MD IMMEDIATELY . EYES:FLUSH WITH LARGE AMOUNTS
OF WATER FOR AT LEAST 15 MINUTES UNTIL ALL PARTICLES ARE WASHED
OUT. INHALATION:REMOVE TO FRESH AIR.
===================== Fire Fighting Measures =====================
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE . NONE:MATERIAL
IS NON-COMBUSTIBLE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NOT ESTABLISHED.
================== Accidental Release Measures ==================
Spill Release Procedures:COLLECT ACCORDING TO GOOD HOUSEKEEPING
PRACTICES. VACUUM OR SCOOP FOR RECOVERY OR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STANDARD INDUSTRIAL HYGIENIC PRACTICE.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN . NOT REQUIRED.
Ventilation:NOT REQUIRED.
Other Protective Equipment:NOT REQUIRED.
Work Hygienic Practices:STANDARD INDUSTRIAL HYGIENIC PRACTICE.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Solubility in Water:SLIGHT
Appearance and Odor:VARIOUSLY PIGMENTED FLAKES, NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NOT ESTABLISHED.
Stability Condition to Avoid:NOT ESTABLISHED.
Hazardous Decomposition Products:NOT ESTABLISHED.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE AND
LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TEAM 505 SANI-BAC ODORLESS DISINFECTANT
CAGE:FO757
CAGE:39712
CAGE:FO757
============= Composition/Information on Ingredients =============
Ingred Name:ALKYL DIMETHYL BENZYL AMMONIUM CHLORIDE
CAS:68424-85-1
Fraction by Wt: 10%
Ingred Name:CHLORIDES
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: DAMAGE. SKIN: IRRITATION.
INGESTION: HARMFUL.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES: DAMAGE. SKIN: IRRITATION. INGESTION:
HARMFUL.
======================= First Aid Measures =======================
First Aid:EYES/SKIN: FLUSH W/WATER FOR AT LEAST 15 MINS. INGESTION:
DRINK LARGE QUANTITIES OF MILK, EGG WHITES, GELATIN SOLUTION, OR
WATER. OBTAIN MEDICAL ATTENTION IN ALL CASES.
================== Accidental Release Measures ==================
Spill Release Procedures:MAY BE COLLECTED W/ABSORBENT MATERIAL.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP OUT OF REACH OF CHILDREN. AVOID
CONTAMINATION OF FOOD. FOR INDUSTRIAL USE. AVOID WETTING SKIN &
CLOTHES.
Other Precautions:READ COMPLETE LABEL FOR ALL CAUTIONS & DIRECTIONS.
============= Exposure Controls/Personal Protection =============
Other Protective Equipment:AS NEEDED
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F
Spec Gravity:0.99
Solubility in Water:COMPLETE
Appearance and Odor:BLUE, CLEAR LIQUID, ODORLESS.
Percent Volatiles by Volume:90%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
SOAPS & ANIONIC SURFACTANTS
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF ACCORDING TO LOCAL POLLUTION
ORDINANCES.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:DEVRAN 929 FLIGHT DECK TOPPING CONVERTER
Preparer's Name:LOUIS F HOLZKNECHT
CAGE:1HK86
CAGE:1HK86
============= Composition/Information on Ingredients =============
Ingred Name:HIGH FLASH AROMATIC NAPHTHA (SARA III) (VAPOR PRESSURE 10
MM HG) (LD50: >5 GM/KG RAT, ORAL; LC50: >3670 PPM RAT, 8 HRS)
CAS:64742-95-6
Fraction by Wt: 20%
Other REC Limits:NONE RECOMMENDED
ACGIH TLV:100 PPM
Ingred Name:PHENOLIC COMPOUND (VAPOR PRESSURE <2 MM HG @ 271F) (LD50:
1.62 G/KG RAT ORAL; LC50: >2 MG/L RAT)
Fraction by Wt: 10%
Other REC Limits:NONE RECOMMENDED
Ingred Name:POLYAMIDE RESIN (VAPOR PRESSURE <1 MM HG) (LD50: 8 GM/KG
RAT, ORAL)
CAS:68082-29-1
Fraction by Wt: 30%
Other REC Limits:NONE RECOMMENDED
Ingred Name:XYLENE (SARA III) (VAPOR PRESSURE 6 MM HG) (LD50: >5 GM/KG
RAT, ORAL)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 40%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:CALCULATED VOC: 516.76 GM/L
RTECS #:9999999VO
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL: RESP TRACT IRRIT
(HEADACHE, DIZZINESS, WEAKNESS, NAUSEA, FATIGUE, UNCONSCIOUSNESS,
RESP ARREST). EYE: IRRIT. SKIN: IRRIT. MAY BE HARMFUL IF ABSORBED
THRU SKIN. INGESTION: STOMACH/INTESTI NAL IRRIT (NAUSEA, VOMITING,
DIARRHEA).CHRONIC: PERMANENT BRAIN & NERVOUS SYSTEM DAMAGE. INHAL:
DUST DISEASE OF LUNGS.
Medical Cond Aggravated by Exposure:NONE, WHEN USED IN ACCORDANCE WITH
SAFE HANDLING AND USE INFORMATION.
======================= First Aid Measures =======================
First Aid:INHAL:GET FRESH AIR. IF CONTINUED DIFFICULTY EXPERIENCED GET
MED AID IMMED. IF BREATHING STOPS, RESTORE USING CPR. GET MED AID
IMMED. EYES: FLUSH IMMEDIATELY WITH LARGE AMOUNTS OF WATER AT LEAST
15 MI NUTES. GET MED AID. SKIN: WASH WITH SOAP & WATER. REMOVED
SOILED CLOTHING. GET MED AID IF IRRITATION PERSISTS. DO NOT INDUCE
VOMITING. ASPIRATION OF VOMITING CAN CAUSE CHEM PNEUMONITIS-CAN BE
FATAL.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:80.0F,26.7C
Lower Limits:1
Extinguishing Media:IN CASE OF FIRE USE CO2 DRY CHEMICAL, FOAM OR OTHER
NFPA APPROVED METHOD FOR TREATING A CLASS B FIRE.
Fire Fighting Procedures:GET PROFSNL FIREMEN.USE FULL PROTECT EQUIP
W/SCBA.WATER SPRAY MAY BE INEFFECTIVE,USE(FOG NOZZLES)TO COOL CNTNR
& PREVENT PRESSURE BUILDUP OR POSSIBLE AUTOIGNIT.
Unusual Fire/Explosion Hazard:KEEP CNTNR CLSD.KEEP FROM
HEAT/IGNIT.VAPOR MAY CAUSE FLASH FIRE,IGNIT EXPLOSIVELY,SPREAD LONG
DISTANCE BEYOND CLOSED DOOR.DUE TO PRESSR BLDUP, CLSD CNTNR MAY *
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE IGNIT SOURCE (FLAME,HOT
SRFC,ELEC,STATIC,FRICTION SPARK).PREVENT BREATHING OF VAPOR.VENT
AREA.BEFORE CLEAN-UP,REFER TO HAZARD CAUTION INFO IN OTHER SECTIONS
OF MSDS.CONTAIN SPILL.REMOVE W/INERT ABSORBNT & NON SPARK
TOOLS.STORE IN CLSD CNTNR.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP FROM HEAT,SPARK,FLAME.DONT
SMOKE.TURN OFF PILOT LIGHT & TURN OFF IGNIT SOURCE,DURING & UNTIL
VAPOR GONE.DONT TRANSFER TO BOTTLES/UNLABELED CNTNR.
Other Precautions:VAPOR IGNITE EXPLOSIVELY,SPREAD LONG DISTANCE &
BEYOND CLSD DOOR.PREVENT BLDUP OF VAPOR BY CONTINUOUS FLOW OF FRESH
AIR.DONT STORE >120F/NEAR FIRE/OPEN FLAME.STORE LRG QTY IN BLDG IN
COMPLY W/OSHA 191 0.106.KEEP CNTNR CLSD.DONT REUSE EMPTIES
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SPRAYED IN OUTDOOR/OPEN AREA OR SAND/GRINDING,
USE NIOSH MECHAN FILTER RESPRTR (RMV SOLID PARTICLES). RESTRICTED
AREA, WEAR NIOSH CHEM/MECHAN FILTER. CONFINED AREA, NIOSH AIR
SUPPLIED RSPRTR/HOOD. USE NIOSH RSPRTR WHEN CUT/WELD HAZING TORCH
Ventilation:GENRL DILUTN/LOCAL EXHAUST VENT TO KEEP BELOW PEL/TLV WHILE
MIXING,APPLICATION,CURING,REMOVE DECOMP FROM WELD/FLAME CUT.
Other Protective Equipment:DO NOT GET ON SKIN. SOLVENT IMPERMEABLE
CLOTHING & BOOTS TO PREVENT SKIN CONTACT ARE RECOMMENDED.
Work Hygienic Practices:REMOVE AND WASH SOILED CLOTHING BEFORE REUSE.
WASH HANDS BEFORE EATING OR SMOKING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:279 TO 541F
Spec Gravity:0.84-1.02
Viscosity:A4-A GARDENER
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:SLIGHT
Appearance and Odor:VISCOUS YELLOW LIQUID, SOLVENT ODOR
Percent Volatiles by Volume:59.71
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:N/K * EXPOSED TO EXTREME HEAT MAY
EXPLODE. NEVER USE WELD/CUT TORCH ON/NEAR CNTNR AS PRODUCT/RESIDUE
MAY IGNITE.**
Hazardous Decomposition Products:MAY CAUSE TOXIC FUMES WHEN HEATED TO
DECOMPOSITION. FUMES MAY CONTAIN CARBON MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE, AND
FEDERAL REGULATIONS. INCINERATE ONLY IN APPROVED FACILITY. DO NOT
INCINERATE CLOSED CONTAINERS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:AMERTROL C REAGENT 4
CAGE:52454
CAGE:52454
============= Composition/Information on Ingredients =============
Ingred Name:METHYL ALCOHOL (METHANOL) (SARA III)
CAS:67-56-1
RTECS #:PC1400000
Fraction by Wt: >10%
OSHA PEL:S,200PPM/250STEL
ACGIH TLV:S,200PPM/250STEL; 93
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ISOPROPYL ALCOHOL (SARA III)
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: >10%
OSHA PEL:400 PPM/500 STEL
ACGIH TLV:400 PPM/500STEL;9192
===================== Hazards Identification =====================
Effects of Overexposure:PROLONG EXPOSURE TO LIQUID/VAPOR MAY CAUSE
DIZZINESS,OPTIC DISORDERS.CNS DAMAGE POSS (SEE SUPP DATA)
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/PLENTY OF H*2O FOR @ LEAST 15 MIN. SKIN: WASH
EXPOSED AREAS W/H*2O;RINSE WELL. INGEST: CALL PHYSICIAN,INDUCE
VOMITING. INHAL: REMOVE TO FRESH AIR,GET MED ATTN.
===================== Fire Fighting Measures =====================
Flash Point:60F,TOC
Extinguishing Media:CO*2,DRY CHEMICAL,FOAM TYPE ONLY
Fire Fighting Procedures:VAPORS HIGHLY FLAMMABLE;USE SMOTHERING
DEVICES.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE SOURCES OF IGNITION. ABSORB ONTO
INERT MATERIAL(SAND,BICARBONATE OF SODA). EVAPORATE W/PLENTY OF
VENTILATION OR IGNITE IN A SAFE,VENTILATED AREA.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPRVD CARTRIDGE RESPIRATOR.
Ventilation:PROVIDE ADEQUATE GENERAL MECH VENT & LOCAL EXHAUST VENT.
Supplemental Safety and Health
EFTS OF OVEREXP: IF INHAL.EYE BURNS IF NOT PROMPTLY REMOVED.POSS FATAL
IF INGEST.DRY,DEFATTING TO SKIN.
================== Physical/Chemical Properties ==================
Spec Gravity:<1
Evaporation Rate & Reference:N/A (MFR)
Solubility in Water:SOLUBLE
Appearance and Odor:CLEAR,WATER-WHITE LIQUID;ALCOHOLIC ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
HEAT,FLAME,IGNITION SOURCE
Stability Condition to Avoid:SOURCES OF IGNITION & FLAMMABLES.
Hazardous Decomposition Products:HIGHLY FLAMMABLE VAPORS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IAW FEDERAL,STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:E-Z-HD, CAT #768
CAGE:JO796
CAGE:25969
CAGE:JO796
============= Composition/Information on Ingredients =============
Ingred Name:BARIUM SULFATE
CAS:7727-43-7
RTECS #:CR0600000
Fraction by Wt: 85.0%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:UNIDENTIFIED COMPONENTS(USED TO AID SUSPENDABILITY &
FLUIDITY),TYPES NOT IDENTIFIED.
Fraction by Wt: UNK
===================== Hazards Identification =====================
Effects of Overexposure:IN RARE CASES FOLLOWING REPEATED
ADMNSTRTION,SEVERE STOMACH CRAMP & DIARR MAY OCCUR;NO SYMPTMS EYES.
======================= First Aid Measures =======================
First Aid:ALTHOUGH NON-IRRITATION,TAKE NORMAL PRECAUTIONARY MEASURES
WASHING OFF THE SKIN W/WATER AND FLUSH EYES WITH WATER.IF
SWALLOWED,FREQUENT CONSUMPTION OF DRINKING WATER
REQUIRED.CONSTIPATION MAY OCCUR AF TER NORMAL INGESTION OF BARIUM
SULFATE SUSPENSION.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:EXTINGUISH WITH AGENT SUITABLE FOR SURROUNDING FIRE
Fire Fighting Procedures:NOT KNOWN
Unusual Fire/Explosion Hazard:NONE NOTED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:USE RESPIRATORY PROTECTION TO AVOID INHALATION
OF DUST.SMALL SPILL:NORMAL CLEAN UP WITH WATER;LG SPILL:COLLECT
MATL BY SWEEPING OR VACUUMING & PLACE IN COVERED DRUMS.FLUSH AWAY
TO SEWER(THE RESIDUE)W/ LG AMTS OF WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY,WELL VENTILATED
AREA. PROTECT FROM PHYSICAL DAMAGE.AVOID ANY PHYSICAL CONTACT. KEEP
CONTAINERS TIGHTLY CLOSED
Other Precautions:NONE INDICATED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED
Ventilation:NORMAL ROOM VENTILATION.
Other Protective Equipment:NORMAL WORK CLOTHING COVERING ARMS & LEGS.
Supplemental Safety and Health
MSDS FM MFR DATED:AUGUST 1985.
================== Physical/Chemical Properties ==================
HCC:N1
Solubility in Water:SLIGHT
Appearance and Odor:PRODUCT IS RADIOPAQUE SUSPENSION.SLIGHT FRUIT ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NOT KNOWN
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:NONE KNOWN
==================== Disposal Considerations ====================
Waste Disposal Methods:KEEP IN COVERED DRUMS,PENDING DISPOSAL. HANDLE &
DISPOSE IN FULL COMPLIANCE WITH ALL APPLICABLE
INTERNATIONAL,FEDERAL,STATE, & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:RICH LUX FASTIME CLEAR-SATIN, 913204
CAGE:85519
CAGE:85519
============= Composition/Information on Ingredients =============
Ingred Name:DIATOMACEOUS EARTH
CAS:68855-54-9
Fraction by Wt: 1-10%
OSHA PEL:6 MG/M3 (MFR)
ACGIH TLV:10 MG/M3 (MFR)
Ingred Name:STODDARD SOLVENT; (PETROLEUM DISTILLATE) LEL: 1.0 % VP: 2.0
@ 25C
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 11-30%
OSHA PEL:500 PPM
ACGIH TLV:100 PPM; 9495
Ingred Name:VM & P NAPHTHA; (PETROLEUM DISTILLATE) LEL: 0.9% VP: .10 @
25C
CAS:64742-89-8
Fraction by Wt: 31-60%
OSHA PEL:100 PPM (MFR)
ACGIH TLV:100 PPM (MFR)
Ingred Name:VINYL TOLUENE MODIFIED ALKYD
CAS:68814-31-3
Fraction by Wt: >3%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:EFTS OF OVEREXP: INTENTIONAL MISUSE BY DELIB CONCENTRATING
& INHALING THE CONTENTS MAY BE HARMFUL OR FATAL.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL: IRRIT OF RESP TRACT. PRLNG
INHAL MAY LEAD TO FATG. DROWS, DIZZ & LTHEAD, HDCH, LACK OF
COORDINATION, NAUS, VOMIT, CNS DEPRESS, ANESTH EFT/NARCOS. SKIN:
IRRIT OF SKIN. PRLNG/RPTD CNTCT CAN CAUSE DERM, DEFAT. EYE: IRRIT
OF EYES. PRLNG/RPTD CNTCT CAN CAUSE BLURRED VISION, REDNESS OF
EYES, TEARING (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:OF EYES, SEVERE EYE IRRIT. INGEST:AMTS
INGESTED INCIDENTAL TO CONSUMER & INDUS HNDLG ARE NOT LIKELY TO
CAUSE INJURY; HOWEVER, INGEST OF LARGER AMTS MAY CAUSE LUNG INFLAMM
& DMG DUE TO ASPIR O F MATL INTO LUNGS. RPTS HAVE ASSOCD RPT& PRLNG
OCCUP OVER-EXP TO SOLV W/PERM BRAIN & NERVOUS SYS DMG. (ING 5)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. RESTORE & SUPPORT CONTINUED
BRTHG. HAVE TRAINED PERSON GIVE OXYGEN IF NEC. GET EMER MED ATTN.
SKIN: WASH OFF QUICKLY W/PLENTY OF H*2O, THEN SOAP & H*2O; REMOVE
CONTAMD CLTH G. WASH CONTAMD CLTHG BEFORE REUSE. EYE: FLUSH IMMED
W/LRG AMTS OF H*2O, ESP UNDER LIDS, FOR AT LEAST 15 MIN. OBTAIN
EMER MED TREATMENT. INGESTION: IF SWALLOWED, OBTAIN MEDICAL
TREATMENT IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:>42F,>6C
Lower Limits:SEE INGRED
Extinguishing Media:DRY CHEMICAL OR FOAM.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . WATER MAY BE USED TO COOL AND PROTECT EXPOSED
CONTAINERS.
Unusual Fire/Explosion Hazard:CLSD CNTNRS MAY EXPLODE WHEN EXPOSED TO
EXTREME HEAT/FIRE. VAPS CAN FOAM EXPLO MIX IN AIR AT ELEVATED TEMP.
MAY DECOMPOSE UNDER FIRE CNDTNS EMITTING (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION (FLAME, HOT
SURFACES, AND ELECTRICAL, STATIC SPARKS). VENTILATE AREA AND AVOID
BREATHING VAPORS. CONTAIN AND REMOVE WITH INERT ABSORBENT MATERIAL
USING NON-SPARKING TOOL S.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE IN SUN OR ABOVE 100
DEGREE F. STORE LARGE QUANTITIES IN BUILDINGS DESIGNED FOR STORAGE
OF FLAMMABLE OR COMBUSTIBLE LIQUIDS.
Other Precautions:DO NOT TAKE INTERNALLY. DO NOT WELD/FLAME CUT W/OUT
PROPER VENT TO INSURE THE AREA IS FREE OF FLAMM VAPS. DO NOT CUT,
PUNCTURE/WELD ON/NEAR THE CNTNR. ENTRANCE INTO CLSD STOR TANKS-USE
APPROP NIOSH AP PROVED RESP/AIRLINE FOR POSS (SUPDAT)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:CONTROL ENVIRONMENTAL CONCENTRATIONS BELOW
APPLICABLE STANDARDS. APPROVED CHEMICAL MECHANICAL FILTER
RESPIRATOR DESIGNED TO REMOVE A COMBINATION OF PARTICULATE AND
VAPORS (NIOSH TC23C OR EQUIVALENT).
Ventilation:ALL APPLICATION AREAS SHOULD BE VENTILATED I/A/W OSHA
REGULATION 29 CFR 1910 DURING USE & UNTIL AREA IS FREE OF VAPORS.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EXPLO HAZ: IRRITANT AND/OR TOXIC GASES. OTHER PREC: EXPOS TO SOLVENT OR
CHEMICAL FUMES. RAGS/WASTE CONTAINING OIL BASED PAINT/VARNISH THAT
PRESENT LARGE AIR-TO-OIL INTERFACE WILL OXIDIZE & MAY IGNITE
SPONTANEOUSLY & SHOULD BE PLACED IN METAL CONTAINER. KEEP OUT OF
THE REACH OF CHILDREN.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>245F,>118C
Vapor Pres:SEE INGRED
Spec Gravity:1.19-1.67
Evaporation Rate & Reference:SLOWER THAN ETHYL ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:38-60
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS, ACIDS, BASES, AMINES.
Stability Condition to Avoid:ELEVATED TEMPERATURES. CONTACT WITH
OXIDIZING AGENTS.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. AVOID DISCHARGE TO NATURAL WATERS.
| 1 | gloves_mandatory |
=======================================================
NIIN: 00-156-5589
Product ID: 7635519G6
Cage: 81755
=======================================================
Preparer Co. when other than Responsible Party Co.
=======================================================
Cage: 81755
Box: 748
=======================================================
Contractor Summary
=======================================================
Cage: 88236
Cage: 99971
Cage: 81755
Box: 748
=======================================================
Item Description Information
=======================================================
Item Manager: FLZ
Item Name: MODULATOR,RADAR
Unit of Issue: EA
UI Container Qty: 1
=======================================================
Ingredients
=======================================================
Cas: 10028-17-8
% Wt: <1
Other REC Limits: 5000 MILLIREM/YR
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: YES
Skin: NO
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: OVEREXPOSURE TO RADIONUCLIDE MAY CAUSE CANCER. SKIN
CONTACT IS A ROUTE OF ENTRY.
Explanation Of Carcinogenicity: NONE
Signs And Symptions Of Overexposure: TRITUM IS A BETA EMITTER. URINE ASSAY FOR
TRITIUM IS THE ONLY MEANS OF MEASURING THE DEGREE OF EXPOSURE.
Medical Cond Aggravated By Exposure: HEALING OF DAMAGED TISSUES MAY BE
PROLONGED.
First Aid: SKIN/EYES: FLUSH W/WATER FOR 15 MINS. INHALATION: REMOVE TO FRESH
AIR. INGESTION: A HIGH ORAL FLUID INTAKE SHOULD BE ADMINISTERED FOLLOWING
TRITIUM EXPOSURE. OBTAIN MEDICAL ATTENTION IN ALL CASES.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: BROKEN/DISASSEMBLED RECEIVER PROTECTOR TUBES MAY EMIT
IONIZING RADIATION.
Waste Disposal Methods: DISPOSE OF BROKEN TUBES AS SPECIFIED IN 10CFR, PART 20
& 10 CFR, PART 30. DISPOSE OF IAW/FEDERAL, STATE & LOCAL REGULATIONS.
RADIOACTIVE MATERIAL, UN2910.
Handling And Storage Precautions: TUBES ARE SEALED SOURCES & NORMAL
HANDLING DOESN'T PRESENT A RADIATION PROBLEM. WHEN HANDLING BROKEN TUBES WEAR
Other Precautions: AVOID RUBBING RADIOACTIVE MATERIAL ONTO THE SKIN. AVOID
INHALING GASES FROM BROKEN TUBES CONTAINING TRITIUM. WASH EXPOSED SKIN AFTER
HANDLING BROKEN TUBES.
=======================================================
Fire and Explosion Hazard Information
=======================================================
=======================================================
Control Measures
=======================================================
Respiratory Protection: IF SPILLED, WEAR RADIONUCLIDE CARTRIDGE RESPIRATOR.
Ventilation: LOCAL EXHAUST
Work Hygienic Practices: WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health: THIS TUBE CONTAINS 6.25 MCI OF TRITIUM.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: -478.4F
M.P/F.P Text: -489.2F
Vapor Pres: 18.317
Spec Gravity: 6
Solubility in Water: COMPLETE
Appearance and Odor: GAS W/NO ODOR
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: TEMP >752F.
Materials To Avoid: OXIDIZERS
Hazardous Decomposition Products: UNBOUND TRITIUM
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: 7635519G6
Cage: 81755
Company Name: LOCKHEED MARTIN CORP
Street: LOCKHEED BLVD
PO Box: 748
Zipcode: 76101
Label Required IND: Y
Date Of Label Review: 12/16/1998
Status Code: C
Label Date: 12/16/1998
Origination Code: G
Hazard And Precautions: OVEREXPOSURE TO RADIONUCLIDE MAY CAUSE CANCER. SKIN
CONTACT IS A ROUTE OF ENTRY.
TRITUM IS A BETA EMITTER. URINE ASSAY FO R
TRITIUM IS THE ONLY MEANS OF MEASURING THE DEGREE OF EXPOSURE.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:HULL SMOOTHING CEMENT PART A
Kit Part:Y
Resp. Party Other MSDS Num.:DOD-C-24176B
Preparer's Name:J. BARTUSIAK
CAGE:19092
CAGE:19092
============= Composition/Information on Ingredients =============
Ingred Name:EPOXIDE RESIN
CAS:25068-38-6
RTECS #:CE6880000
Minumum % Wt:30.
Maxumum % Wt:50.
OSHA PEL:NO INFO FOUND
ACGIH TLV:NO INFO FOUND
Ingred Name:ALKYL GLYCIDYL ETHERS
CAS:68609-96-1
Minumum % Wt:5.
Maxumum % Wt:10.
OSHA PEL:NO INFO FOUND
ACGIH TLV:NO INFO FOUND
Ingred Name:SILICON DIOXIDE AMORPHOUS
CAS:67762-90-7
< Wt:5.
OSHA PEL:20 MPPCF
ACGIH TLV:10 MG/M3
Ingred Name:CALCIUM CARBONATE
CAS:1317-65-3
RTECS #:EV9580000
Minumum % Wt:50.
Maxumum % Wt:70.
OSHA PEL:15 MG/M3
ACGIH TLV:10 MG/M3
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN IRRITATION, NAUSEA, HEADACHE,
VAPORS MAY IRRITATE RESPIRATORY PASSAGES. IRRITATING TO EYES.
EFFECT OF ACUTE AND CHRONIC OVEREXPOSURE: SKIN: POSSIBLE IRRITATION
AND SENSITIZATION ON PROLONGED OR R EPEATED CONTACT. EYES:
IRRITATION. INHALATION: NAUSEA AND HEADACHE, ALLERGIC RESPIRATORY
CONDITIONS. INGESTION: ABDOMINAL DISCOMFORT.
Explanation of Carcinogenicity:NO
Effects of Overexposure:SEE HEALTH HAZARDS ACUTE AND CHRONIC .
Medical Cond Aggravated by Exposure:ALLERGIES, ECZEMA OR SKIN
CONDITIONS. ASTHMA OR OTHER RESPIRATORY CONDITIONS.
======================= First Aid Measures =======================
First Aid:SKIN: WASH WITH SOAP AND WATER. EYES: FLUSH WITH WATER FOR
AT LEAST 15 MINUTES, CALL PHYSICIAN. NHALATION: REMOVE TO FRESH
AIR. GIVE OXYGEN IF BREATHING IS DIFFICULT. CONTACT A PHYSICIAN .
IN GESTION: DO NOT INDUCE VOMITING. IF CONSCIOUS GIVE LARGE
QUANTITIES OF WATER. GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:>135.C, 275.F
Autoignition Temp:Autoignition Temp Text:N.I.F.
Upper Limits:NOT ESTAB
Extinguishing Media:WATER FOG, FOAM, CO2, DRY CHEMICAL.
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING INCLUDING NIOSH
APPROVED SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:NONE KNOWN. AUTOIGNITION TEMP: NO
INFORMATION FOUND.
================== Accidental Release Measures ==================
Spill Release Procedures:AVOID CONTACT WITH EYES AND SKIN. MIX WITH
NON-COMBUSTIBLE ABSORBENT. SCRAPE INTO A POPERLY LABELED DRY
SEALABLE CONTAINER. WASH RESIDUE CONTAMINATED AREA WITH SOAP AND
WATER.
Neutralizing Agent:MIXING WITH PART B OF THIS SYSTEM IN THE PROPER
RATIO WILL PRODUCE A NON-HAZARDOUS PLASTIC.
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLE IN A WELL VENTILATED AREA. USE
PROTECTIVE MEASURES TO AVOID CONTACT WITH EYES, SKIN AND CLOTHING.
AVOID BREATHING VAPORS. WASH WITH SOAP AND WATER AFTER HANDLING
THIS PRODUCT. STORE PRODUCT IN COOL, DRY AREA IN TIGHTLY SEALED
CONTAINERS.
Other Precautions:USE GOOD HOUSEKEEPING PROCEDURES AND PERSONAL
CLEANLINESS. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE. DISCARD
HEAVILY CONTAMINATED CLOTHING, SHOES, LEATHER ARTICLES, ETC.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IN CONFINED OR ENCLOSED SPACES, USE NIOSH
APPROVED ORGANIC VAPOR RESPIRATORY PROTECTION.
Ventilation:USE ONLY IN AREAS WITH GOOD MECHANICAL VENTILATION. LOCAL
EXHAUST PREPERRED.
GLASSES.
Other Protective Equipment:EYE WASH STATION SHOULD BE LOCATED IN
IMMEDIATE WORKING AREA. IMPERVIOUS APRON TO PROTECT FROM SKIN OR
CLOTHING CONTACT. DELUGE SHOWER MEETING ANSI DESIGN CRITERIA .
Supplemental Safety and Health
PHYSICAL AND CHEMICAL PROPERTIES (CONT): MAGNATISM (MILLIGAUS): N.A.
CORROSION RATE (LBS/YR): N.A.
================== Physical/Chemical Properties ==================
Boiling Pt:>204.4C, 400.F
Decomp Temp:=204.4C, 400.F
Decomp Text:>400F
Vapor Pres:< 0.1 @ 68F/20C
Vapor Density:>3 @ 68F
Spec Gravity:1.8
VOC Pounds/Gallon:3
Solubility in Water:SLIGHT
Appearance and Odor:WHITE PASTE, PLASTIC ODOR.
Percent Volatiles by Volume:<1
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MINERAL ACIDS, OXIDIZERS.
Stability Condition to Avoid:STORE BELOW 125F, 52C.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE. SMOKE
AND UNIDENTIFIED ORGANIC COMPOUNDS MAY ALSO FORM DURING COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:ALL DISPOSAL METHODS MUST BE IN COMPLIANCE WITH
ALL FEDERAL, STATE / PROVINCIAL, AND LOCAL LAWS AND REGULATIONS.
REGULATIONS MAY VARY IN DIFFERENT LOCATIONS. WASTE CHARACTERIZATION
AND COMPLIANCE WITH APPLICABLE LAWS ARE THE RESPONSIBILITY SOLELY
OF THE WASTE GENERATOR.
=================== MSDS Transport Information ===================
Transport Information:PROPER SHIPPING NAME: NOT REGULATED BY D.O.T. UN
NO.: NA. LIMITED QTY: NA.REPORT QTY: NO. HAZARD CLASS: NOT
REGULATED.LABELS REQUIRED: NONE.D.O.T. EXEMPT/CCN: NA.US
POSTAL SERVICE REGULATI ONS: NA. UNIT CONTAINER: N/P.
===================== Regulatory Information =====================
Federal Regulatory Information:EPA HAZARDOUS WASTE HAZARD/CODE: N/P.
HAZARDOUS WASTE CHARACTERISTICS: N/P.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:MICHLIN MALATHION EC-5
Resp. Party Other MSDS Num.:LA MIRADA
Preparer's Name:ERIC NACHLAS
CAGE:8H736
CAGE:8H736
CAGE:8Y149
============= Composition/Information on Ingredients =============
Ingred Name:MALATHION (SARA III)
CAS:121-75-5
RTECS #:WM8400000
Fraction by Wt: 56.56%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:S, 15 MG/M3
ACGIH TLV:S, 10 MG/M3; 9293
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:AROMATIC PETROLEUM SOLVENT
CAS:8002-05-9
RTECS #:SE7449000
Fraction by Wt: 36.54%
Other REC Limits:NONE RECOMMENDED
Ingred Name:INERT INGREDIENTS
Fraction by Wt: 6.9%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL-RATS) 2103 MG/KG (TOXICANT)
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION: RESPIRATORY
IRRITATION. EYES: IRRITANT. SKIN: IRRITANT. INGESTION:
GASTROINTESTINAL DISTURBANCES. CHRONIC: CHOLINESTERASE INHIBITION.
Explanation of Carcinogenicity:NONE OF THE COMPONENTS OF THIS PRODUCT
HAVE SHOWN ANY EVIDENCE OF BEING CARCINOGENIC.
Effects of Overexposure:LABORED BREATHING, VOMITING, TREMORS, DIARRHEA,
CONVULSIONS, HEADACHE, LACRIMATION, SALIVATION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR, GIVE CPR/ OXYGEN IF NEEDED.
GET MEDICAL ATTENTION. EYES/SKIN: FLUSH WITH WATER FOR 15 MINUTES.
GET MEDICAL ATTENTION FOR EYE CONTACT. INGESTION: RINSE MOUTH. DO
NOT IN DUCE VOMITING. CALL PHYSICIAN OR POISONCONTROL CENTER. TAKE
ONE OR TWO 1/100 GRAIN ATROPINE TABLETS AND REPEAT IN 1 HOUR.
===================== Fire Fighting Measures =====================
Flash Point Method:TOC
Flash Point:100F,38C
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICALS, CHEMICAL FOAM
Fire Fighting Procedures:USE SELF-CONTAINED BREATHING APPARATUS,
PREVENT SPREAD OF CONTAMINATED RUNOFF.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY CAUSE
PRODUCTION OF HAZARDOUS DECOMPOSITION PRODUCTS.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR RESPIRATORY PROTECTION AND PROTECTIVE
CLOTHING. STOP SOURCE IF POSSIBLE. KEEP SPILL FROM ENTERING STREAMS
OR LAKES. USE ABSORBENT TO SOAK UP SPILL. COLLECT ABSORBED
MATERIALS IN PROPER WASTE DISP OSAL DRUMS.
Neutralizing Agent:NONE SPECIFIED.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY, WELL VENTILATED,
LOW FIRE RISK AREA. PROTECT FROM PHYSICAL DAMAGE. AVOID ANY
PHYSICAL CONTACT. KEEP CONTAINERS TIGHTLY CLOSED.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. DO NOT CONTAMINATE
FEED, FOOD STUFFS, OR WATER SUPPLIES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SCBA IF INVOLVED IN FIRE, OTHERWISE NIOSH/MSHA-
APPROVED CHEMICAL CARTRIDGE RESPIRATOR WITH ORGANIC VAPOR CARTRIDGE
IN COMBINATION WITH A DUST, MIST, AND FUME FILTER IF TLV IS
EXCEDED.
Ventilation:PROVIDE LOCAL EXHAUST. USE IN WELL VENTILATED AREA.
Other Protective Equipment:WEAR PROTECTIVE CLOTHING DESIGNED TO PREVENT
SKIN CONTACT. EYE WASH STATION, SAFETY SHOWER, AND OXYGEN SUPPLY.
Work Hygienic Practices:DONOT TAKE INTERNALLY. AVOID SKIN CONTACT. WASH
SKIN AFTER USING PRODUCT. DO NOT EAT DRINK OR SMOKE IN WORK AREA.
Supplemental Safety and Health
STORED MATERIALS SHOULD BE INSPECTED PERIODICALLY.
================== Physical/Chemical Properties ==================
HCC:F4
NRC/State Lic Num:NONE
Boiling Pt:B.P. Text:156F,69C
Vapor Pres:.0004 @30C
Spec Gravity:1.23
Solubility in Water:EMULSIFIABLE
Appearance and Odor:CLEAR BROWN TO COLORLESS LIQUID, SOLVENT ODOR
Percent Volatiles by Volume:36.5
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ARAMITE,ENDRIN,CARBARYL,SULPHENONE,TOXAPHENE,DODINE,
FERLAM,THIRAM,ZINEB,ZIRIM.
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAMES
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON MONOXIDE,
PHOSPHOROUS OXIDE, MALAOXON.
==================== Disposal Considerations ====================
Waste Disposal Methods:KEEP IN COVERED DRUMS PENDING DISPOSAL. HANDLE
AND DISPOSE IN FULL COMPLIANCE WITH ALL APPLICABLE FEDERAL, STATE
AND LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:TAN BOX SAVER, 7090
Preparer's Name:PETER M. JANKOWSKI
CAGE:0T7G9
CAGE:0T7G9
============= Composition/Information on Ingredients =============
Ingred Name:2-BUTANONE; (METHYL ETHYL KETONE) (SARA 313) (CERCLA)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 11-30%
OSHA PEL:200 PPM
ACGIH TLV:200 PPM; 300 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ACETONE (SARA 313) (CERCLA)
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 11-30%
OSHA PEL:1000 PPM
ACGIH TLV:750 PPM; 1000 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TOLUENE (SARA 313) (CERCLA)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 1-10%
OSHA PEL:200 PPM
ACGIH TLV:50 PPM, S
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:PROPANE, 2-METHYL-; (ISOBUTANE)
CAS:75-28-5
RTECS #:TZ4300000
Fraction by Wt: 11-30%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 11-30%
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 1-10%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL: HIGH VAPOR CONCS MAY
RSLT IN DIZZ, HDCH OR UNCON. INGEST: NOT LIKELY. EYES: MAY CAUSE
IRRIT. POSSIBLE CORNEAL INJURY. SKIN: PRLNGD CONTACT WILL CAUSE
DEFATTING OF SKIN LEADING TO IRRIT & DERM. NOT LIKELY TO BE
ABSORBED IN TOXAMOUNTS. INTENTIONAL MISUSE BY DELIB CONCENTRATING &
INHALING (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: CONTENTS CAN BE HARMFUL/FATAL.
CHRONIC: TOLUENE APPEARS ON THE NAVY LIST OF OCCUP CHEM
REPRODUCTIVE HAZARDS. SEEK CONSULTATION FROM APPROP HEALTH
PROFESSIONALS CONCERNING LATEST HAZARD LIST INFO & SAFE HNDLG &
EXPOS INFO . PRLNGD EXPOS ABOVE OSHA PERMISSIBLE LIMS MAY RSLT IN
KIDNEY & LIVER DAMAGE.
Medical Cond Aggravated by Exposure:MAY INCREASE MYOCARDIAL
IRRITABILITY. AVOID EPINEPHRINE OR SIMILAR DRUGS IF AT ALL
POSSIBLE.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR AT LEAST 15 MINUTES OR UNTIL
IRRITATION SUBSIDES. SKIN: REMOVE ALL CONTAMINATED CLOTHING. WASH
SKIN WITH SOAP AND WATER. INHALATION: REMOVE FROM EXPOSURE
IMMEDIATELY. IF BRE ATHING IS STOPPED OR IRREGULAR, BEGIN
ARTIFICIAL RESPIRATION AND ADMINISTER OXYGEN. INGESTION: DO NOT
INDUCE VOMITING. DRINK PLENTY OF WATER.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:<20F,<-7C
Lower Limits:1%
Upper Limits:13%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:TREAT AS CYLINDERS OF COMPRESSED GAS.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. REMOVE ALL SOURCES OF
IGNITION. CLEAN UP WITH INERT MATERIALS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AEROSOL CONTAINER: DO NOT STORE IN
DIRECT SUNLIGHT, NEAR OPEN FLAMES OR AT TEMPS EXCEEDING 120F. DO
NOT SMOKE WHILE SPRAYING. USE ONLY AS DIRECTED.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN . RESPIRATORY PROTECTION PROGRAM SHOULD BE
IN ACCORDANCE WITH 29 CFR 1910.134.
Ventilation:LOCAL EXHAUST IS ADEQUATE.
Other Protective Equipment:PROTECTIVE CLOTHING AND EQUIPMENT: SEE 29
CFR 1910, 133 & 132.
Work Hygienic Practices:WASH SKIN WITH SOAP AND WATER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Vapor Pres:45-50 PSIG
Vapor Density:>1
Spec Gravity:<1
Evaporation Rate & Reference:<1 (ETHER=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:TAN; KETONE ODOR.
Percent Volatiles by Volume:75-80
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID ALKALINE MATERIALS AND MINERAL ACIDS.
Stability Condition to Avoid:OPEN FLAMES OR ELECTRICAL ARCS.
Hazardous Decomposition Products:BURNING CAN PRODUCE CARBON MONOXIDE
AND/OR CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE
AND FEDERAL REGULATIONS. AEROSOL CONTAINER: DO NOT PUNCTURE OR
INCINERATE. EMPTY CONTAINERS MAY BE DISPOSED OF THROUGH NORMAL
CHANNELS. FULL OR PARTIALLY FILLED CONTAINERS ARE CONSIDERED
HAZARDOUS WASTE.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:BATTERY, STORAGE
CAGE:74025
CAGE:74025
============= Composition/Information on Ingredients =============
Ingred Name:CADMIUM (SARA III)
CAS:7440-43-9
RTECS #:EU9800000
Other REC Limits:NONE SPECIFIED
OSHA PEL:SEE 1910.1027
ACGIH TLV:0.01 MG/M3 DUST;9394
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:CADMIUM HYDROXIDE
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.1 MG/M3 (CD FUME)
ACGIH TLV:0.05 MG/M3 (CD FUME)
Ingred Name:NICKEL (SARA III)
CAS:7440-02-0
RTECS #:QR5950000
Other REC Limits:NONE SPECIFIED
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3; 9192
Ingred Name:NICKEL HYDROXIDE (SARA III)
CAS:12054-48-7
RTECS #:QR7040000
Other REC Limits:1 MG/M3 AS NI
OSHA PEL:1 MG NI/M3
ACGIH TLV:0.1 MG NI/M3; 9293
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:POTASSIUM HYDROXIDE (SARA III)
CAS:1310-58-3
RTECS #:TT2100000
Other REC Limits:NONE SPECIFIED
OSHA PEL:C, 2 MG/M3
ACGIH TLV:C 2 MG/M3; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:IRRITATION OF EYES, NOSE AND
THROAT.DRYNESS OF THROAT,MOUTH,NAUSEA. CHRONIC: REPEATED CONTACT
CAUSES IRRITATION AND SKIN BURNS. REPEATED EXPOSURE TO MIST MAY
CAUSE DAMAGE TO UPPER RESPIRATORY TR ACT, CAN DAMAGE
SKIN,EYE,MOUTH,THROAT AND STOMACH TISUES. CADMIUM COMPOUNDS CAN
CAUSE LUNG AND KIDNEY INJURIES.
Explanation of Carcinogenicity:NICKEL AND CADMIUM COMPOUNDS ARE LISTED
AS ANTICIPATED CARCINOGENS BY NTP & EPA.
Effects of Overexposure:ALKALI VAPORS MAY CAUSE IRRITATION OF EYES,
NOSE AND THROAT. BREATHING OF MIST MAY PRODUCE RESPIRATORY
DIFFICULTY. CONTACT WITH EYES AND SKIN CAUSES BURNS & TISSUE
DAMAGE. POTASSIUM HYDROXIDE IS A COR ROSIVE CHEMICAL. OVEREXPOSURE
TO CADMIUM& ITS COMP'DS MAY CAUSE DAMAGE TO KIDNEYS AND LUNGS.
Medical Cond Aggravated by Exposure:PULMONARY, LUNGS, KIDNEYS AND SKIN
DISEASES.
======================= First Aid Measures =======================
First Aid:FLUSH CONTACTED AREA WITH LARGE AMOUNTS OF WATER FOR AT LEAST
15 MINUTES. REMOVE CONTAMINATED CLOTHING AND GET MEDICAL ATTENTION.
IF SWALLOWED, GIVE LARGE VOLUMES OF WATER. DO NOT INDUCE VOMITING,
OBT AIN MEDICAL ATTENTION. EYEWASH AND SHOWER STATIONS SHOULD BE
AVAILABLE.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:NONCOMBUSTIBLE. FOR SURROUNDING FIRE USE WATER FOG,
CARBON DIOXIDE, FOAM, OR DRY CHEMICAL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. EVACUATE AREA. COOL
FIRE EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:SPILL-ABSORB WITH NEUTRAL ABSORBANT AND WASH
RESIDUE WITH FIVE TO SIX VOLUMES OF WATER.
Neutralizing Agent:USE NEUTRAL ABSORBANTS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE-STORE AWAY FROM REACTIVE
MATERIALS, OPEN FLAMES AND SOURCES OF IGNITION.
Other Precautions:INDUSTRIAL TYPE NEUTRAL ABSORBANT HOULD BE KEPT IN
SAME GENERAL AREA FOR EMERGENCY USE. WASH HANDS THOROUGHLY AFTER
HANDLING TERMINALS INORDER TO AVOID INGESTION OF CADMIUM, NICKEL
AND THEIR COMPOUNDS .
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESPIRATOR REQUIRED WHEN PEL IS EXCEEDED OR
EMPLOYEE WITNESSES RESPIRATORY IRRITATION.
Ventilation:WHEN PEL IS EXCEEDED LOCAL EXHAUST IS PREFERRED. USE
ADEQUATE VENTILATION TO MAINTAIN EXPOSURE BELOW PEL.
Other Protective Equipment:ALKALI-RESISTANT APRONS, BOOTS AND
PROTECTIVE CLOTHING.
Work Hygienic Practices:GOOD PERSONAL HYGIENE AND WORK PRACTICES ARE
MANDATORY.
Supplemental Safety and Health
AVOID PROLONGED OVERCHARGE IN CONFINED AREAS.
================== Physical/Chemical Properties ==================
HCC:B1
Boiling Pt:B.P. Text:1322F,717C
Spec Gravity:2.044(KOH)
pH:ALKALI
Appearance and Odor:BATERY,WET;FILLED WITH ALKALI
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS AND ACIDS.
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES AND OTHER SOURCES
OF IGNITION
Hazardous Decomposition Products:ALKALI FUMES AND CADMIUM & NICKEL
OXIDE FUMES.
==================== Disposal Considerations ====================
Waste Disposal Methods:PLACE IN ALKALI-RESISTANT CONTAINERS. DISPOSAL
MUST BE IN ACCORDANCE WITH APPLICABLE GOVERNMENT REGULATIONS. CELLS
AND BATTERIES MAY BE RETURNED AT SENDERS EXPENSE TO MARATHON
TECHNOLOGIES.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:4913 M/M PIPE SEALANT
Preparer's Name:DON POKRAS
CAGE:53417
CAGE:53417
============= Composition/Information on Ingredients =============
Ingred Name:ETHYLENE, TETRAFLUORO- POLYMER (POLYTETRAFLUOROETHYLENE),
PTFE, TEFLON
CAS:116-14-3
RTECS #:KX4025000
Ingred Name:POLYETHYLENE GLYCOL DIMETHACRYLATE*93/1*
CAS:25852-47-5
Ingred Name:OCTANOL, OCTYL ALCOHOL
CAS:111-87-5
RTECS #:RH6550000
Ingred Name:BISPHENOL-A PROPYLENE OXIDE FUMARATE (POLYMER),POLYESTER
RESIN*93-3*
CAS:39382-25-7
Ingred Name:SILICA, MICA, MUSCOVITE
CAS:12001-26-2
RTECS #:VV8760000
ACGIH TLV:3 MG/CUM
Ingred Name:CUMENE HYDROPEROXIDE
CAS:80-15-9
RTECS #:MX2450000
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (LAB ANIMAL): 5000 MG/KG 1
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: DERMATITIS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INTOXICATION, NAUSEA, HEADACHE, DIZZINESS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. EYES: FLUSH W/WATER FOR 15
MINUTES. SKIN: FLUSH W/WATER. INGESTION: DON'T INDUCE VOMITING.
KEEP INDIVIDUAL CALM. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:300F
Extinguishing Media:FOAM, CO2, DRY CHEMICAL
================== Accidental Release Measures ==================
Spill Release Procedures:SOAK UP W/ABSORBENT. STORE IN PARTLY FILLED
CLOSED CONTAINER UNTIL DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE TEMPERATURES >32F & <110F.
STORE AT MODERATE TEMPERATURES & REFRIGERATED.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. READ ENTIRE LABEL
BEFORE USING PRODUCT.
============= Exposure Controls/Personal Protection =============
Ventilation:GENERAL EXHAUST
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:300F
Vapor Pres:10
Spec Gravity:1.21
Solubility in Water:NEGLIGIBLE
Appearance and Odor:OPAQUE WHITE PASTE W/ALCOHOLIC ODOR
Percent Volatiles by Volume:10
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MAY ATTACK SOME THERMOPLASTICS
Stability Condition to Avoid:TEMPERATURES >110F & <32F.
Hazardous Decomposition Products:TOXIC FLUORIDES
==================== Disposal Considerations ====================
Waste Disposal Methods:BURY OR INCINERATE IN ACCORDANCE W/FEDERAL,
STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:F77A503 MACHINE TOOL GRAY
CAGE:54636
CAGE:54636
============= Composition/Information on Ingredients =============
Ingred Name:BUTANOL, N-BUTYL ALCOHOL, PROPYL CARBINOL, BUTYL ALCOHOL
CAS:71-36-3
RTECS #:EO1400000
Fraction by Wt: 4%
Other REC Limits:300 MG/CUM
OSHA PEL:100 PPM
ACGIH TLV:C 152 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:2-BUTOXYETHANOL (ETHYLENE GLYCOL MONOBUTYL ETHER), BUTYL
CELLOSOLVE, BUTYL GLYCOL, GLYCOL ETHER EB * 96-2 *
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: 10%
Other REC Limits:25 PPM (SKIN)
OSHA PEL:50 PPM (SKIN)
ACGIH TLV:25 PPM (SKIN)
Ingred Name:METHYL ETHYL KETONE, 2-BUTANONE *96-2*
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 2%
Other REC Limits:590 MG/CUM
OSHA PEL:200 PPM
ACGIH TLV:590 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:TITANIUM DIOXIDE, TITANIUM OXIDE (SUSPECTED ANIMAL
CARCINOGEN, IARC GROUP 3)*96-2*
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 3%
OSHA PEL:15 MG/CUM
ACGIH TLV:10 MG/CUM (DUST)
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 56.8%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:OVEREXPOSURE-EYES, SKIN & RESPIRATORY
SYSTEM IRRITATION. MAY CAUSE NERVOUS SYSTEM DEPRESSION. EXTREME
OVEREXPOSURE MAY RESULT IN UNCONSCIOUSNESS & POSSIBLY DEATH.
PROLONGED OVEREXPOSURE TO SOLVENTS MA Y CAUSE ADVERSE EFFECTS TO
THE LIVER, URINARY, BLOOD-FORMING & REPRODUCTIVE SYSTEMS. (SEE
SUPP)
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, HEADACHE, DIZZINESS, NAUSEA, LOSS
OF COORDINATION, REDNESS, ITCHING/BURNING.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. KEEP WARM
& QUIET. SKIN: WASH THOROUGHLY W/SOAP & WATER. EYES: FLUSH W/WATER
FOR 15 MINS. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:115F
Lower Limits:1.1
Upper Limits:11.2
Extinguishing Media:CO2, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:WEAR FULL PROTECTIVE EQUIPMENT W/SCBA. WATER
SPRAY MAY BE INEFFECTIVE. IF WATER IS USED, FOG NOZZLES ARE
PREFERABLE. USE WATER TO COOL CLOSED CONTAINERS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE IGNITION SOURCES. VENTILATE & REMOVE
W/INERT ABSORBENT.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP FROM HEAT & OPEN FLAME. USE
APPROVED BONDING & GROUNDING PROCEDURES. KEEP CONTAINER CLOSED WHEN
NOT IN USE. DON'T TAKE INTERNALLY.
Other Precautions:TRANSFER TO APPROVED CONTAINERS W/COMPLETE &
APPROPRIATE LABELING. KEEP OUT OF REACH OF CHILDREN. AVOID
BREATHING VAPORS. INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING
& INHALING THE CONTENTS CAN B E HARMFUL/FATAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF PERSONAL EXPOSURE CAN'T BE CONTROLLED BELOW
APPLICABLE LIMITS BY VENTILATION, WEAR A PROPERLY FITTED ORGANIC
VAPOR/PARTICULATE RESPIRATOR APPROVED BY NIOSH/MSHA. WHEN
SANDING/ABRADING, WEAR A DUST/ MIST RESPIRATOR APPROVED BY
NIOSH/MSHA.
Ventilation:LOCAL/GENERAL EXHAUST VENTILATION.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
HEALTH HAZARDS CONT'D: METHYL ETHYL KETONE MAY INCREASE THE NERVOUS
SYSTEM EFFECTS OF OTHER SOLVENTS. REPEATED/PROLONGED OVEREXPOSURE
TO SOLVENTS MAY CAUSE PERMANENT BRAIN & NERVOUS SYSTEM DAMAGE. AVO
ID CONTACT W/SKIN & EYES.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:174-340F
Vapor Density:>1
Spec Gravity:1-1.2
VOC Grams/Liter:3.47
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:MACHINE TOOL GRAY
Percent Volatiles by Volume:72-79
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HEAT, OPEN FLAMES.
Hazardous Decomposition Products:BY FIRE: CO2, CO.
==================== Disposal Considerations ====================
Waste Disposal Methods:MAY BE HAZARDOUS & MUST BE TESTED FOR
IGNITABILITY. PRODUCTS CONTAINING METHYL ETHYL KETONE MAY ALSO
REQUIRE EXTRACTABILITY TESTING. INCINERATE IN APPROVED FACILITY.
DON'T INCINERATE CLOSED CONTAINERS . DISPOSE OF IAW/FEDERAL, STATE
& LOCALREGULATION
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:C370, ULTRAJET
Preparer's Name:M.WATKINS
CAGE:2M589
CAGE:21267
CAGE:2M589
============= Composition/Information on Ingredients =============
Ingred Name:DICHLORODIFLUOROMETHANE (SARA III)
CAS:75-71-8
RTECS #:PA8200000
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ozone Depleting Chemical:1
Ingred Name:SUPP DATA:BECAUSE OF POSS INCR RISK OF ELICITING CARDIAC
DYSRYTHMIAS, CATECHOLINAMINE DRUGS,SUCH AS EPINEPHRINE, (ING 3)
RTECS #:9999999ZZ
Ingred Name:ING 2: SHOULD BE USED ONLY AS LAST RESORT IN LIFE
THREATENING EMERGENCIES.
RTECS #:9999999ZZ
Ingred Name:EXPLO HAZ: INCLUDE CHLORIDE, FLUORIDES AND PHOSGENE .
RTECS #:9999999ZZ
Ingred Name:EFTS OF OVEREXP:SENSIT OF MYOCARDIUM TO EPINEPHRINE IN LAB
ANIMALS & COULD HAVE SIMILAR EFT IN HUMANS. (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5:ADRENOMIMETICS (E.G., EPINEPHRINE)MAY BE
CONTRAINDICATED EXCEPT FOR LIFE-SUSTAINING USES IN HUMANS
ACUTELY/(ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6: CHRONICALLY EXPOSED TO CHLOROCARBONS .
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL: VAPS IS HEAVIER THAN AIR & CAN
CAUSE SUFFOCATION BY REDUCING O2 AVAIL FOR BRTHG. EYE:LIQ CONT CAN
CAUSE FROSTBITE. SKIN: LIQ CAN CAUSE SEV DMG FROM FROSTBITE. NOTE:
IN SCREENING STUDIES W/EXPER IMENTAL ANIMALS, EXPOS AT APPROX 5000
PPM (V/V) & ABOVE, FOLLOWED BY LRG INTRAVENOUS EPINEPHRINE
CHALLENGE, (SUPP DATA)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:INHAL: BRTHG HIGH CONC OF VAP CAN CAUSE LT
HEAD, GIDDINESS, SHORT OF BRTH/MAY LEAD TO NARCOSIS, CARDIAC IRREG,
UNCON/ DEATH. SKIN: LIQ CONT MAY CAUSE FROSTBITE. IRRIT/REDNESS MAY
OCCUR DUE TO DEFAT. I NGEST: MAY CAUSE NAUS & VOMIT. EYE: CONTACT
MAY CAUSE FROSTBITE. CHLOROFLUOROCARBON (CFC) MATERIALS HAVE
PRODUCED (ING 5
Medical Cond Aggravated by Exposure:CARDIOVASCULAR DISEASE.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR & CALL PHYS. IF NOT BRTHG, GIVE
ARTF RESP, PREFERRABLY MOUTH-TO-MOUTH. IF BRTHG DFCLT GIVE O2. DO
NOT GIVE EPINEPHRINE/SIMILAR DRUGS. SKIN: TREAT FOR FROSTBITE.
FLUSH W/H2O. IF IRRIT OCCURS/PERSISTS, SEEK MED ATTN. INGEST: NO
SPECIFIC INTERVENTION IS INDICATED AS CMPD IS NOT LIKELY TO BE HAZ
BY INGEST. HOWEVER, CONSULT PHYS IF NEC. DO NOT INDUCE VOMIT AS
HAZ(SUPP DATA)
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:NONE
Extinguishing Media:NONFLAMMABLE. USE MEDIA SUITABLE FOR SURROUNDING
FIRE CONDITIONS .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED PRESSURE DEMAND SCBA
AND FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:PRESS CNTNRS MAY VENT, RUPTURE/EXPLO &
ADD TO FLYING & FALLING DEBRIS. INTENSE HEAT MAY CAUSE DECOMP
W/EVOLUTION OF HALOGEN GASES.THERM DECOMP PRODS MAY (ING 4)
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. REMOVE OPEN FLAMES OR OTHER
SOURCES OF IGNITION. COLLECT SPILLED PRODUCT WITH ABSORBENT
MATERIAL AND PLACE IN CLOSED STEEL DRUMS FOR PROPER DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE NEAR SOURCES OF HEAT, IN
DIRECT SUNLIGHT, OR WHERE TEMPERATURES EXCEED 120F. DO NOT PUNCTURE
OR DAMAGE CONTAINERS. ROTATE STOCK.
Other Precautions:NO SMOKING IN AREA OF USE. DO NOT USE IN GENERAL
VICINITY OF ARC WELDING, OPEN FLAMES OR HOT SURFACES. HEAT AND/OR
UV RADIATION MAY CAUSE FORMATION OF HCL AND/OR PHOSGENE .
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:NORM VENT FOR STD MFR PROC IS GEN ADEQ.LOC EXHST SHD BE
USED WHEN LRG AMTS ARE RELS.MECH VENT SHD BE USED IN LOW PLACES.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
HAZ DECOMP PRODS: ACIDS & POSS CARBONYL HALIDES. CHLORIDES, FLUORIDES &
PHOSGENE . HLTH HAZ: HAS INDUCED SERIOUS CARDIAC IRREG. FIRST AIR
PROC: OF ASPIR MATL INTO LUNGS IS GREATER HAZ THAN ALLOW ING IT TO
PASS THRU INTESTINAL TRACT. EYE: IMMED FLUSH W/H2O FOR AT LEAST 15
MIN. SEEK MED ATTN. NOTES TO PHYS: (ING 2)
================== Physical/Chemical Properties ==================
HCC:G3
Boiling Pt:B.P. Text:-22F,-30C
Vapor Pres:80PSIG@77F
Vapor Density:4.2@ 77F
Spec Gravity:1.30 (H2O=1)
Evaporation Rate & Reference:<1 (BUTYL ACETATE=1)
Solubility in Water:0.028 (WT)
Appearance and Odor:COLORLESS LIQUIFIED GAS; SLIGHT ETHEREAL ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ALKALI AND ALIALINE EARTH METALS-POWDERED AL, ZN, BE, OR MG.
Stability Condition to Avoid:OPEN FLAMES, RED HOT SURFACES.
Hazardous Decomposition Products:CMPD CAN BE DECOMP BY HIGH TEMP (OPEN
FLAMES, GLOWING METAL SURFS, ETC.) FORMING HYDROCHLORIC &
HYDROFLUORIC (SUPP DATA)
==================== Disposal Considerations ====================
Waste Disposal Methods:COMPLY WITH ALL FEDERAL, STATE, AND LOCAL
REGULATIONS. DO NOT PUNCTURE OR INCINERATE AEROSOL CANS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:A-1 ADHESIVE
CAGE:DO043
CAGE:DO043
CAGE:98911
============= Composition/Information on Ingredients =============
Ingred Name:NO INGREDIENT FOR THIS FORMULATION_INGREDIENT
===================== Hazards Identification =====================
Effects of Overexposure:PRIMARY IRRIT SKIN W/PRLNG/RPTD CNTCT. MINOR
TRANSIENT EYE IRRIT. NO CORNEAL INJURY LIKELY.
======================= First Aid Measures =======================
First Aid:SKIN: REMOVE W/SOAP & WATER OR WATERLESS SKIN CLEANER. REMOVE
CONTAM CLOTHING & WASH BEFORE REUSE. EYES: FLUSH, IF ANY ILL
EFFECTS DEVELOP GET MEDICAL ATTN. INH: REMOVE TO FRESH AIR. INGEST:
NO KNOWN ANTIDOTE. TREAT SYMPTOMATICALLY.
===================== Fire Fighting Measures =====================
Flash Point:230F PMCC
Extinguishing Media:FOAM, CO*2, DRY CHEMICALS
Fire Fighting Procedures:AVOID BREATHING SMOKE
Unusual Fire/Explosion Hazard:NO UNUSUAL HAZARDS
================== Accidental Release Measures ==================
Spill Release Procedures:SOAK UP W/ABSORBENT MATERIAL. SCOOP UP.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL PLACE. PRACTICE GOOD
CAUTION & PERSONAL CLEANLINESS TO AVOID SKIN & EYE CONTACT. AVOID
BRTHNG VAPORS OF HEATED MATERIAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT ORDINARILY REQUIRED
Ventilation:MFR RECM LOCAL EXHST ONLY IF HEATED. MECH: NOT NORM NEEDED.
Other Protective Equipment:AS NECESSARY TO PREVENT SKIN CONTACT
Supplemental Safety and Health
SPECIFIC GRAVITY+ 1.60 +/- .05.
================== Physical/Chemical Properties ==================
Solubility in Water:NEGLIGIBLE
Appearance and Odor:RED-BROWN, VISCOUS LIQ. MILD AROMATIC ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Hazardous Decomposition Products:CO, ALDEHYDES, ACIDS, ETC.
==================== Disposal Considerations ====================
Waste Disposal Methods:MFR RECM CONTROLLED BURNING OR BURIAL. DISPOSE
IN ACCORDANCE W/FED., STATE & LOCAL REGULATIONS.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:FLEXLITE HT-105 PVC TUBING
CAGE:03890
CAGE:03890
============= Composition/Information on Ingredients =============
Ingred Name:NON-HAZARDOUS INGREDIENTS
Fraction by Wt: 100%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NONE KNOWN.
Explanation of Carcinogenicity:NONE SPECIFIED BY MANUFACTURER.
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:NONE NORMALLY NEEDED.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER; MATERIAL IS NORMALLY SELF-EXTINGUISHING IN
NORMAL ATMOSPHERE.
Fire Fighting Procedures:USE SELF-CONTAINED BREATHING APPARATUS FOR
FIRES IN CONFINED AREAS SUCH AS WAREHOUSES.
Unusual Fire/Explosion Hazard:WHEN FORCED TO BURN, THESE TUBES WILL
CONTRIBUTE MOSTLY CARBON MONOXIDE, CARBON DIOXIDE AND HYDROGEN
CHLORIDE AS BASES AND SMOKE.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NORMAL HOPUSEKEEPING. RECOMMEND
STORAGE AWAY FROM LARGE AMOUNTS OF EASILY COMBUSTIBLES, HEAT AND
IGNITION SOURCES.
Other Precautions:NONE KNOWN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IN THE EVENT OF FIRE, WEAR SELF-CONTAINED
BREATHING APPARATUS.
Ventilation:LOCAL EXHAUST RECOMMENDED AS GENERAL GOOD SAFETY PRACTICE
AND MANUFACTURING POLICY.
Other Protective Equipment:NONE NORMALLY REQUIRED.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
ITEM IS AN ARTICLE UNDER 29 CFR 1910.1200 AND NO MSDS IS REQUIRED.
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:1.31
Evaporation Rate & Reference:NON-VOLATILE
Solubility in Water:INSOLUBLE
Appearance and Odor:FLEXIBLE, THIN-WALLED PLASTIC TUBING. MILD,
NON-OFFENSIVE ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:NO
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:TEMPERATURES IN EXCESS OF 400F.
Hazardous Decomposition Products:MAINLY CARBON MONOXIDE, CARBON DIOXIDE
AND HYDROGEN CHLORIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:SANITARY LANDFILL OR INCINERATOR. IF
INCINERATION IS USED; RECOGNIZE THAT CARBON MONOXIDE, CARBON
DIOXIDE AND HYDROGEN CHLORIDE ARE GENERATED AND APPLY APPROPRIATE
LOCAL, STATE AND FEDERAL REGULATIONS .
| 0 | gloves_not_mandatory |
===================== Product Identification =====================
Product ID:FORMULA 2000
CAGE:53542
CAGE:53542
============= Composition/Information on Ingredients =============
Ingred Name:NITRIC ACID (SARA III)
CAS:7697-37-2
RTECS #:QU5775000
OSHA PEL:2 PPM/4 STEL
ACGIH TLV:2 PPM/4 STEL; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:THIOUREA (SARA III)
CAS:62-56-6
RTECS #:YU2800000
Fraction by Wt: 5%
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION OR DAMAGE TO TISSUE.
SKIN: IRRITATION. INHALATION: MAY CAUSE IRRITATION TO NASAL MUCOUS
MEMBRANES & RESPIRATORY TRACT. INGESTION: IRRITATION OR CORROSION
TO DIGESTIVE TRACT.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES: IRRITATION OR DAMAGE TO TISSUE. SKIN:
IRRITATION. INHALATION: IRRITATION TO NASAL MUCOUS MEMBRANES &
RESPIRATORY TRACT. INGESTION: IRRITATION OR CORROSION TO DIGESTIVE
TRACT.
======================= First Aid Measures =======================
First Aid:EYES: IRRIGATE W/WATER FOR AT LEAST15 MINS. SKIN: RINSE RINSE
W/COPIOUS AMOUNTS OF WATER &/OR WASH W/SOAP & WATER. INHALATION:
REMOVE VICTIM TO FRESH AIR. IF NOT BREATHING, HAVE CERTIFIED
INDIVIDUAL A DMINISTER FIRST AID/CPR. INGESTION: ADMINISTER 2-4
GLASSES OF MILK OR WATER. CONTACT PHYSICIAN OR POISON CONTROL
CENTRAL IMMEDIATELY.
===================== Fire Fighting Measures =====================
Extinguishing Media:ANY APPLICABLE TO PRIMARY CAUSE OF FIRE.
Fire Fighting Procedures:WEAR NIOSH APPROVED SELF-CONTAINED BREATHING
APARATUS WHEN ENTERING BUILDING.
================== Accidental Release Measures ==================
Spill Release Procedures:DIKE SPILL & SOAP UP W/SAND OR A COMMERCIALLY
AVAILABLE ACID SPILL KIT. SWEEP UP ABSORBENT & PLACE IN A HAZARDOUS
WASTE CONTAINER.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T STORE FOOD, DRINK OR TOBACCO IN
AREA WHERE THEY MAY BECOME CONTAMINATED W/THIS MATERIAL. STORE IN
WELL-VENTILATED AREA.
Other Precautions:KEEP CONTAINERS TIGHTLY CLOSED. DON'T STORE NEAR HEAT
OR <32FF.
============= Exposure Controls/Personal Protection =============
Ventilation:LOCAL EXHAUST/MECHANICAL: USE ONLY IN ADEQUATELY VENTILATED
ROOM
Other Protective Equipment:RUBBER OR PLASTIC APRON
Work Hygienic Practices:REMOVE/WASH CONTAMINATED CLOTHING.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F
Spec Gravity:1.058
pH:1.0
Evaporation Rate & Reference:(BU AC = 1): AS WATER
Solubility in Water:COMPLETE
Appearance and Odor:WATER CLEAR; SLIGHT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ALKALI
Stability Condition to Avoid:UNDILUTED CONCENTRATES (COMPONENTS 1 & 2)
MUSTN'T BE MIXED. DON'T STORE NEAR HEAT OR <32F.
Hazardous Decomposition Products:NITRATES OF OXYGEN
==================== Disposal Considerations ====================
Waste Disposal Methods:REMOVE FREE LIQUID & DISPOSE OF IN ACCORDANCE
W/FEDERAL, STATE & LOCAL REGULATIONS.
======================================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:OL 400 E/600 E/810 E SERIES TONER,52107201
Resp. Party Other MSDS Num.:58093101 DOCUMENT # 1906
CAGE:IO870
CAGE:08HF7
Contract Num:SP0450-00-M-D721
CAGE:0S0F8
CAGE:0EC53
CAGE:25405
CAGE:IO870
Contract Num:SP0450-99-M-NC44
CAGE:0YGF0
============= Composition/Information on Ingredients =============
Ingred Name:STYRENE BUTYLACRYLATE COPOLYMER OR ACRYLIC ACID BUTYL ESTER
POLYMER WITH STYRENE
CAS:25767-47-9
= Wt:91.
Other REC Limits:NONE RECOMMENDED
OSHA PEL:TWA 15 MG/M3 TDUST
ACGIH TLV:TLV 10 MG/M3 TDUST
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Minumum % Wt:5.
Maxumum % Wt:7.
Other REC Limits:NONE RECOMMENDED
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3; 9596
Ingred Name:POLYPROPYLENE
CAS:9003-07-0
RTECS #:TR5000000
< Wt:3.
Other REC Limits:NONE RECOMMENDED
Ingred Name:SILICON DIOXIDE (AMORPHOUS)
CAS:67762-90-7
< Wt:1.
Other REC Limits:NONE RECOMMENDED
OSHA PEL:6 MG/M3
ACGIH TLV:10 MG/M3
===================== Hazards Identification =====================
LD50 LC50 Mixture:NO DATA PROVIDED BY RESPONSIBLE PARTY.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:STYRENE-BUTYL ACRYLATE COPOLYMER -
SUBCUTANEOUS IMPLANTATION IN RATS HAS INDUCED TUMORS AT
IMPLEMENTATION SITE. CARBON BLACK - IRRITATION, CONJUNCTIVITIS,
COMEAL HYPOPLASIA OF EYES; MINOR IRRITATION & ECZEMA OF SKIN;
IRRITAION & BRONCHITIS OF LUNGS. LONG TERM EXPOSURE MAY BE
ASSOCIATED WITH LUNG CANCER. POLYPROPYLENE - SUBCUTANEOUS
IMPLEMENTATION IN RATS HAS INDUCED TUMORS AT IMPLEMENTATION SITE.
AMORPHOUS FUMED SILICA - OVEREXPOSURE ASSOCIATED WITH CAUSING LUNG
IRRITATION & PNEUMOCONIOSIS. LONG TERM INHALATION EXPOSURE MAY BE
ASSOCIATED WITH PRODUCING TUMORS IN LAB ANIMALS.
Explanation of Carcinogenicity:MSDS STATES THAT CARBON BLACK,
POLYPROPYLENE, AND AMORPHOUS FUMED SILICA ARE GROUP 3 "NOT
CLASSIFIBLE" BY IARC.
Effects of Overexposure:EYES: IRRITATION. SKIN: IRRITATION. RESPIRATORY
TRACT: IRRITATION.
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING EYE
PROBLEMS OR IMPAIRED RESPIRATORY FUNCTION MAY BE MORE SUSCEPTIBLE
TO THE EFFECTS OF THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:INHALED:MOVE TO FRESH AIR. SEEK MEDICAL ATTENTION. EYES:
FLUSH EYES WITH LARGE QUANTITIES OF COOL WATER FOR 15 MNUTES,
KEEPING THE EYE LIDS OPEN WITH FINGERS. SEEK MEDICAL ATTENTION.
SKIN: WASH WITH S OAP & WATER. INGESTED: DILUTE BY GIVINGTWO
GLASSES OF WATER AND INDUCE VOMITING BY ADMINISTERING SYRUP OF
IPECAC (FOLLOW MANUFACTURER'S INSTRUCTIONS). NEVER GIVE ANYTHING BY
MOUTH OR INDUCE VOMITING I F PERSON IS UNCONSCIOUS. SEEK MEDICAL
ATTENTION. SMALL AMOUNTS OF TONER OR THE SKIN OR CLOTHING CAN
EASILY BE REMOVED WITH SOAP & COLD WATER. HOT WATER MAKES TONER
HARDER TO REMOVE.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WATER, CARBON DIOXIDE, FOAM OR DRY CHEMICAL.
Fire Fighting Procedures:DO NOT USE METHODS THAT MAY CREATE A DUST
CLOUD, SUCH AS HIGH PRESSURE WATER AND/OR STEAM.
Unusual Fire/Explosion Hazard:ORGANIC COMPONENTS DECOMPOSE AT 200-455 C
(392-851 F). MATERIAL MAY EXPLOSIVELY COMBUST WHEN FINELY SUSPENDED
IN AIR. THERMAL DECOMPOSITION OF ORGANIC COMPONENTS MAY RESULT IN
RELEASE OF OXIDES OF CAR BON AND NITROGEN.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL SPILLS: REMOVE IGNITION SOURCES. CLEAN
UP SPILL WITH WET CLOTH. LARGE SPILLS: REMOVE IGNITION SOURCES.
SPILL WITH SCOOP, BEING CAREFUL NOT TO GENERATE A LOT OF DUST.
Neutralizing Agent:NO DATA PROVIDED BY RESPONSIBLE PARTY.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED. STORE AWAY FROM
STRONG OXIDIZING AGENTS. MINIMIZE DUST GENERATION AND ACCUMULATION.
Other Precautions:AVOID CONTACT WITH EYES. USE WITH ADEQUATE
VENTILATION. WASH THOROUGHLY AFTER HANDLING. KEEP OUT OF REACH OF
CHILDREN. DO NOT BREATHE DUST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NORMALLY REQUIRED. FOR LARGE SPILLS, USE
NIOSH APPROVED FULL FACE PIECE RESPIRATOR WITH HEPA CARTRIDGE
DURING CLEAN UP.
Ventilation:OUTSIDE OF NORMAL VENTILATION, NOT NORMALLY REQUIRED.
Other Protective Equipment:NONE. DLA-HMIS STAFF: EYE BATH, WASHING
FACILITIES.
Work Hygienic Practices:NO DATA PROVIDED BY RESPONSIBLE PARTY. DLA-HMIS
STAFF: OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND RECOMMENDED
PROCEDURES.
Supplemental Safety and Health
NO DATA PROVIDED BY RESPONSIBLE PARTY.
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:=110.C, 230.F
Decomp Temp:=200.C, 392.F
Decomp Text:200-455C (RANGE)
Spec Gravity:1.15
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLACK GRANULES, NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID EXPOSURE TO STRONG OXIDIZERS.
Stability Condition to Avoid:DUST FORMATION, TEMPERATURES ABOVE
200C/392F.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY RESULT IN
RELEASE OF OXIDES OF CARBON AND NITROGEN.
=================== Toxicological Information===================
Toxicological Information:NO DATA PROVIDED BY RESPONSIBLE PARTY.
===================== Ecological Information =====================
Ecological:NO DATA PROVIDED BY RESPONSIBLE PARTY.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT OR DISPOSAL MAY BE SUBJECT
TO FEDERAL, STATE OR LOCAL REGULATIONS. INCINERATE OR LANDFILL.
=================== MSDS Transport Information ===================
Transport Information:NO DATA PROVIDED BY RESPONSIBLE PARTY.
===================== Regulatory Information =====================
SARA Title III Information:THIS PRODUCT IS NOT REGULATED UNDER SECTION
313 OF SARA, TITLE III.
Federal Regulatory Information:NO DATA PROVIDED BY RESPONSIBLE PARTY.
State Regulatory Information:NO DATA PROVIDED BY RESPONSIBLE PARTY.
======================= Other Information =======================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:6835, 8037740 WHITE
CAGE:DO804
CAGE:DO804
CAGE:38360
============= Composition/Information on Ingredients =============
Ingred Name:ETHANOL, 2-BUTOXY-; (ETHYLENE GLYCOL MONOBUTYL ETHER)
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: 30-50%
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM
Ingred Name:ACETIC ACID, 2-METHOXY-1-METHYLETHYL ESTER; (PROPYLENE
GLYCOL MONOMETHYL ETHER ACETATE)
CAS:108-65-6
RTECS #:AI8295000
Fraction by Wt: 10-30%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:NON-HAZARDOUS INGREDIENTS
Fraction by Wt: BALANCE
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPDAT:(NIOSH) PUBLICATION NO. 90-118). ".
RTECS #:9999999ZZ
Ingred Name:WASTE DISP METH:HAZ. CONT FED, STATE & LOC AUTH FOR DISP
INFO. CONSULT 40 CFR 261 IDENTIFICATION & LISTING OF HAZ WASTE.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC:DETERM IF EXISTING CONCS ARE W/IN ESTABLISHED
RECOM/PELS.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:CENTRAL NERVOUS SYSTEM,
SKIN, EYES. EYES:IRRITATION, REDNESS, TEARING, BLURRED VISION.
SKIN:IRRITATION, DEFATTING, DERMATITIS. INHALATION:IRRITATION,
DIZZINESS, WEAKNESS, FATIGUE. INGEST ION:IRRITATION, NAUSEA,
VOMITING, DIARRHEA. CHRONIC:NOTE TO MD:CHRONIC OVEREXP TO ING 1 IN
ANIMALS HAS (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZS:BEEN REPORTED TO CAUSE ANEMIA, LIVER
ABNORMS, KIDNEY DMG & LUNG DMG & BLOOD ABNORMS. SKIN ABSORPTION OF
ING 1 MAY POTNTLY CONTRIBUTE TO OVERALL EXPOS TO THIS MATL. APPROP
MEASURES SHOULD BETAKEN TO PVNT ABSORP SO THAT PEL &/OR TLV IS
NOT INVALIDATED. SKIN ABSORP MAY POTNTLY CONTRIBUTE TO OVERALL
(SUPP DATA)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH WITH WATER FOR AT LEAST 15 MINUTES. CALL A
PHYSICIAN IMMEDIATELY. SKIN:WASH WITH SOAP AND WATER. LAUNDER
CONTAMINATED CLOTHING BEFORE REUSE. GET MEDICAL ATTETNION.
INHALATION:REMOVE TO FRES H AIR. IF BREATHING IS DIFFICULT GET
MEDICAL ATTENTION IMMEDIATELY. INGESTION:DO NOT INDUCE VOMITING.
GET MEDICAL ATTENTION IMMEDIATELY.
===================== Fire Fighting Measures =====================
Flash Point:116F,47C
Extinguishing Media:DRY CHEMICAL, CO*2, ALCOHOL FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR AND MAY
TRAVEL ALONG THE GROUND AND MAY BE IGNITED AT DISTANT LOCATIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIM ALL SOURCES OF IGNIT. ABSORB SPILLED MATL
W/VERMICULITE/FLOOR ABSORB. DISPOSE OF CONTAM MATLS PROPERLY. USE
OSHA STANDARD:29 CFR 1910.120 HAZ WASTE OPERATIONS & EMER
RESPONSE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:CNTNRS OF MATLS MAY BE HAZ WHEN
EMPTIED, SINCE EMPTIED CNTNRS RETAIN PROD RESIDUES WHICH CAN
GENERATE VAPORS WITHIN THE FLAMMABLE LIMITS.
Other Precautions:FOR FLAM/COMBUST PRODS FOLLOW STOR & HNDLG GUIDELINES
PRESENTED IN NFPA 30 FLAMM & COMBUST LIQS CODE. USE OF HAZ CHEM MAY
REQ SUPP VENT FOR PROT OF PERS & FOR CONTROLLING FIRE/EXPLO HAZ.
QUALIFIED IND EPENDENT TESTING COMPANY CAN (ING 6)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SUFFICIENT TO MAINTAIN OPERATOR EXPOSURE BELOW
APPLICABLE OCCUPATIONAL EXPOSURE STANDARDS. ENGINEERING OR
ADMINISTRATIVE CONTROLS OR NIOSH/MSHA APPRVD RESPIRATORS CAN BE
USED TO REDUCE EXPOSURES. ENGI NEERING CONTROLS ARE PREFERRED BY
OSHA.
Ventilation:SUFFICIENT TO MAINTAIN OPERATOR EXPOS BELOW APPLIC OCCUP
EXPOS STANDARDS. SEE INGS SECTION FOR KNOWN EXPOS INFO.
Other Protective Equipment:EMERGENCY EYE WASH & DELUGE SHOWER WHICH
MEET ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EFTS OF OVEREXP:EXPOS TO ING 2. APPROP MEASURES SHOULD BE TAKEN TO PVNT
ABSORP SO THAT EXPOS LIMS ARE NOT INVALIDATED. "ANIMAL STUDIES
CLEARLY DEMONSTRATED DOSE-RELATED ADVERSE EFTS ON CNS, HEMATOPOIE
TIC TISS, BLOOD, KIDNEYS & LIVER, ASSOCW/ADMIN OF ETHYLENE GLYCOL
MONO BUTYL ETHER (EGBE) (EXTRACTED FROM DHHS (ING 4)
================== Physical/Chemical Properties ==================
Vapor Pres:VERY LOW
Evaporation Rate & Reference:LOW
Solubility in Water:MODERATE
Appearance and Odor:WHITE LIQUID OR SEMI-SOLID INK WITH A MILD, FRUITY
ODOR.
Percent Volatiles by Volume:40
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT AND FLAME.
Hazardous Decomposition Products:CO, CO*2.
==================== Disposal Considerations ====================
Waste Disposal Methods:UNDER RESOURCE CONSERVATION & RECOVERY ACT
RCRA), IT IS RESPONSIBILITY OF GENERATOR OF WASTE TO DETERM, AT
TIME OF DISP, WHETHER WASTE GENERATED MEETS FED/STATE HAZ WASTE
CRITERIA. USERS, TRANSFORMS, MIX, PROCESSES, ETC, MAY RENDER RSLTG
MATL (ING 5)
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:K-700 LUBRICANT
CAGE:61167
CAGE:61167
============= Composition/Information on Ingredients =============
Ingred Name:MINERAL OIL, HYDROTREATED (MILD), HEAVY NAPHTHENIC
DISTILLATE, PETROLEUM; (HYDRTREATD NAPTHENIC DISTILLATE)
CAS:64742-52-5
RTECS #:PY8035000
Other REC Limits:5.0 MG/M3 MFR
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INGEST:UNKNOWN, BUT AS WITH ALL
INDUSTRIAL CHEMICALS, EXERCISE DUE CAUTION.
Explanation of Carcinogenicity:MILDLY REFINED MINERAL OIL:IARC
MONOGRAPHS, SUPPLEMENT, VOL 7, PG 252, 1987:GROUP 1.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTF
RESP) . INGEST:INDUCE VOMITING. CALL PHYSICIAN IMMEDIATELY.
SKIN:WASH WITH SOAP AND WATER. EYES:FLUSH WITH COPIOUS AMOUNTS OF
WATER OR PHYSIOLOGICAL SALINE SOLUTION FOR AT LEAST 15 MINUTES.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:NON-FLAMMABLE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:USE OIL ABSORBENT MATERIAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE.
Other Precautions:NONE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:LOCAL:SATISFACTORY.
Other Protective Equipment:NONE
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:0
Vapor Density:1
Spec Gravity:0.98
Solubility in Water:EMULSIFIES
Appearance and Odor:TRANSPARENT LIQUID WITH AMINE ODOR.
Percent Volatiles by Volume:50
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDIC MATERIALS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:INCOMPLETE COMBUSTION MAY YIELD CO AND
NITROGEN OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS . BY INCINERATION OR CONTRATOR.
| 1 | gloves_mandatory |
=======================================================
NIIN: 00-251-5049
Product ID: CORROSION PREVENTIVE PETROLATUM, SPRAYING APP 972D801
Cage: 0FTT5
=======================================================
Preparer Co. when other than Responsible Party Co.
=======================================================
Cage: 0FTT5
=======================================================
Contractor Summary
=======================================================
Cage: 0FTT5
=======================================================
Item Description Information
=======================================================
Item Manager: GSA
Item Name: CORROSION PREVENTIVE COMPOUND
Unit of Issue: CN
Quantitative Expression: 00000000005GL
UI Container Qty: 1
Type of Container: METAL
=======================================================
Ingredients
=======================================================
Cas: 6447-58-5
% Wt: 57.50
Other REC Limits: NONE RECOMMENDED
OSHA PEL: 500 PPM
ACGIH TLV: 100 PPM
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: MAY CAUSE EYE IRRIT. SKIN:REPEATED SKIN EXPOSR TO LRG QTY
MAY RESULT IN ABSORPTN OF HARMFUL AMTS. INGEST:SINGLE DOSE ORAL
TOXICITY-MODERATE.EXCESSIVE EXPOSR MAY CAUSE CENTRAL NERVOUS SYSTEM
EFFECTS,CA RDIOPULMONARY EFFECT(METABOLIC ACIDOSIS)& KIDNEY FAILURE.
INHAL:VAPOR MINIMAL(LOW VAPOR PRESSURE)IF HEATED SPRAYED-IRRIT
Signs And Symptions Of Overexposure: MAY CAUSE EYE IRRITATION. PROLONGED
CONTACT WITH SKIN MAY CAUSE DEFATTING AND IRRITATION OF SKIN.
Medical Cond Aggravated By Exposure: OPEN CUTS AND SORES.
First Aid: FOR CONTACT WITH SKIN OR CLOTHES, WASH WITH SOAP AND WATER. FOR
CONTACT WITH EYES, FLUSH WITH WATER FOR 15 MINUTES AND CONSULT A
PHYSICIAN/OPHTHALMOLOGIST IF IRRITATION PERSISTS. IF SWALLOWED, GIVE LA RGE
AMOUNTS OF WATER OR MILK AND GET IMMEDIATE MEDICAL AID.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: PICK UP SPILLAGE WITH ABSORBENT MATERIAL. FLUSH AREA
WITH WATER.
Waste Disposal Methods: DISPOSE OF IN ACCORDANCE WITH APPLICABLE FEDERAL,
STATE, AND LOCAL REGULATIONS.
Handling And Storage Precautions: KEEP OUT OF REACH OF CHILDREN. STORE IN DRY
COOL PLACE.
Other Precautions: AVOID CONTACT WITH EYES AND SKIN. USE WITH GOOD VENTILATION.
DO NOT CONTAMINATE FOOD, FEED OR WATERWAYS.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: 118F,48C
Lower Limits: 0.7
Upper Limits: 6.0
Extinguishing Media: DRY CHEMICAL, CARBON DIOXIDE, HALON, FOAM, OR WATER SPRAY
IS RECOMMENDED.
Fire Fighting Procedures: KEEP FIRE EXPOSED CNTNR COOL W/WATER SPRAY.WEAR
SCBA.AVOID SPREADING BURN LIQ W/WATER.USE SHIELDING TO PROTECT PERSONNEL FROM
BURSTING, RUPTURING, VENTING CNTNR
Unusual Fire/Explosion Hazard: COMBUSTIBLE, MAY BE IGNITED BY HEAT, SPARKS,
FLAME OR OTHER SOURCES OF IGNITION. VAPORS MAY TRAVEL CONSIDERABLE DISTANCES
TO SOURCE OF IGNITION WHERE MAY IGNITE
=======================================================
Control Measures
=======================================================
Respiratory Protection: NONE NEEDED BELOW TLV
Ventilation: LOCAL EXHAUST PREFERRED. MECHANICAL (GENERAL): ACCEPTABLE AT POINT
OF SPRAY OR MIST RELEASE.
Other Protective Equipment: SAFETY SHOWERS AND EYEWASH STATIONS.
Work Hygienic Practices: DO NOT CONTAMINATE FOOD, FEED OR WATER. WASH HANDS
AFTER HANDLING PRODUCT.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: 154 TO 204C
Vapor Pres: 3.1 @ 25C
Spec Gravity: 0.818 (WATER=1)
Evaporation Rate & Reference: 0.12 (BU AC=1)
Solubility in Water: NEGLIGIBLE
Percent Volatiles by Volume: 58.5
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Materials To Avoid: OXIDIZING MATERIALS, STRONG ACIDS AND BASES.
Hazardous Decomposition Products: NORMAL COMBUSTION PRODUCTS FROM BURNING. CO2
& CO. DON'T BREATHE VAPORS OR FUMES. WEAR APPROPRIATE PROTECTIVE EQUIPMENT.
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
Transportation Information
=======================================================
Trans ID NO: 61338
Product ID: CORROSION PREVENTIVE PETROLATUM, SPRAYING APP 972D801
Review Date: 02/24/1995
Multiple KIT Number: 0
Review IND: Y
Unit Of Issue: CN
Container QTY: 1
Type Of Container: METAL
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: DNL
DOT Proper Shipping Name: COATING SOLUTION
DOT PSN Modifier: (INCLUDES SURFACE TREATMENTS OR COATINGS USED FOR INDUSTRIAL
OR OTHER PURPOSES SUCH AS VEHICLE UNDERCOATING, DRUM OR BARREL LINING)
Hazard Class: 3
UN ID Num: UN1139
DOT Packaging Group: III
Label: 3
Special Provision: B1,T7,T30
Packaging Exception: 150
Non Bulk Pack: 203
Bulk Pack: 242
Max Qty Pass: 60 L
Max Qty Cargo: 220 L
Vessel Stow Req: A
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: ENF
IMO Proper Shipping Name: COATING SOLUTION o
IMO PSN Modifier: (INCLUDES SURFACE TREATMENTS OR COATINGS USED FOR INDUSTRIAL
PURPOSES SUCH AS VEHICLE UNDER-COATING, DRUM OR BARREL LINING)
IMDG Page Number: 3321
UN Number: 1139
UN Hazard Class: 3.3
IMO Packaging Group: III
Subsidiary Risk Label: -
EMS Number: 3-05
MED First Aid Guide NUM: 310
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: GZN
IATA UN ID Num: 1139
IATA Proper Shipping Name: COATING SOLUTION +
IATA PSN Modifier: (INCLUDES SURFACE TREATMENTS OR COATINGS USED FOR INDUSTRIAL
OR OTHER PURPOSES SUCH AS VEHICLE UNDERCOATING, DRUM OR BARREL LINING)
IATA UN Class: 3
IATA Label: FLAMMABLE LIQUID
UN Packing Group: III
Packing Note Passenger: 309
Max Quant Pass: 60L
Max Quant Cargo: 220L
Packaging Note Cargo: 310
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: GZN
AFI Proper Shipping Name: COATING SOLUTION
AFI Hazard Class: 3
AFI UN ID NUM: UN1139
AFI Packing Group: III
Special Provisions: P5
Back Pack Reference: A7.3
=======================================================
HAZCOM Label
=======================================================
Product ID: CORROSION PREVENTIVE PETROLATUM, SPRAYING APP 972D801
Cage: 0FTT5
Company Name: LHB INDUSTRIES
Street: 8833 FLEISCHER PLACE
Zipcode: 63134
Label Required IND: Y
Date Of Label Review: 12/16/1998
Status Code: C
Label Date: 12/16/1998
Origination Code: G
Hazard And Precautions: MAY CAUSE EYE IRRIT. SKIN:REPEATED SKIN EXPOSR TO LRG
QTY MAY RESULT IN ABSORPTN OF HARMFUL AMTS. INGEST:SINGLE DOSE ORAL
TOXICITY-MODERATE.EXCESSIVE EXPOSR MAY CAUSE CENTRAL NERVOUS SYSTEM
EFFECTS,CA RDIOPULMONARY EFFECT(METABOLIC ACIDOSIS)& KIDNEY FAILURE.
INHAL:VAPOR MINIMAL(LOW VAPOR PRESSURE)IF HEATED SPRAYED-IRRITMAY CAUSE EYE
IRRITATION. PROLONGED CONTACT WITH SKIN MAY CAUSE DEFATTING AND IR RITATION
OF SKIN.
=======================================================
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:STA-PATCH
CAGE:53798
CAGE:53798
============= Composition/Information on Ingredients =============
Ingred Name:PETROLEUM OIL (NO. 2 DIESEL), DIESEL FUEL & OIL
CAS:68334-30-5
RTECS #:HZ1800000
Fraction by Wt: 5%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NONE
Explanation of Carcinogenicity:NONE
Effects of Overexposure:NONE
======================= First Aid Measures =======================
First Aid:SKIN: REMOVE W/PETROLEUM DISTILLATE SOLVENT & THEN WASH
W/SOAP & WATER.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:>300F
Extinguishing Media:WATER, CO2, DRY CHEMICAL, FOAM
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:SHOVEL MATERIAL BACK INTO DRUM. CLEAN ANY
RESIDUE W/OIL SOLUBLE DETERGENT. IF MATERIAL IS NOT SUITED TO BE
RETURNED TO DRUM, DISPOSE OF MATERIAL IN A RECEPTACLE HEADED FOR A
LANDFILL.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED WHEN NOT IN USE.
STORE INDOORS DURING WINTER. AVOID CONTACT W/SKIN.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. FOR INDUSTRIAL &
INSTITUTIONAL USE ONLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE
Ventilation:LOCAL EXHAUST: NORMAL.
Other Protective Equipment:NONE
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Solubility in Water:IMMISCIBLE
Appearance and Odor:A BLACK AGGREGATE SOLID W/A PETROLEUM DISTILLATE
ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:LANDFILL, FOLLOW FEDERAL, STATE & LOCAL
ORDINANCES.
| 1 | gloves_mandatory |
===================== Product Identification =====================
Product ID:DICYCLOHEXYLCARBODIIMIDE, 119 1923
CAGE:GO467
CAGE:ACRSR
CAGE:GO467
============= Composition/Information on Ingredients =============
Ingred Name:CARBODIIMIDE, DICYCLOHEXYL-; (DICYCLOHEXYLCARBODIIMIDE)
CAS:538-75-0
RTECS #:FF2160000
Fraction by Wt: 100%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION:POISON. VAPOR FROM MOLTEN
MATERIAL MAY BE FATAL IF INHALED; EXPOSURES TO LOW CONCENTRATIONS
IN ANIMAL INHALATION STUDIES HAVE RESULTED IN ACUTE AND CHRONIC
INFLAMMATORY REACTIONS IN TISSUE AND SYSTEMIC TOXICITY, INCLUDING
TESTICULAR ATROPHY AND LIVER NECROSIS. CAUSES IRRITATION. DUST
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:HARMFUL IF INHALED. SKIN:POISON.
MOLTEN MATERIAL MAY BE FATAL IF ABSORBED THROUGH THE SKIN. DUST
HARMFUL IF ABSORBED THROUGH THE SKIN. CAUSES BURNS. EYE:CAUSES
BURNS. INGESTION:HARMFUL IF SWA LLOWED.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. TREAT SYMPTOMATICALLY. CALL A
PHYSICIAN IMMEDIATELY. SKIN:IMMEDIATELY FLUSH SKIN WITH PLENTY OF
WATER FOR AT LEAST 15 MINUTES. CALL A PHYSICIAN IMMEDIATELY.
EYE:IMMEDIATELY FLUSH EYES WITH PLENTY OF WATER FOR AT LEAST 15
MINUTES AND CALL A PHYSICIAN IMMEDIATELY. INGESTION:IF CONSCIOUS,
GIVE 1-2 GLASSES OF MILK OR WATER AND INDUCE VOMITING. CALL A
PHYSICIAN IMMEDIATELY.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER SPRAY; DRY CHEMICAL; CARBON DIOXIDE.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . USE WATER SPRAY TO KEEP FIRE EXPOSED CONTAINERS COOL.
Unusual Fire/Explosion Hazard:FIRE/EXCESSIVE HEAT MAY PRODUCE HAZARDOUS
DECOMP PRODUCTS. THIS MATERIAL IN SUFFICIENT QUANTITY & REDUCE
PARTICLE SIZE IS CAPABLE OF CREATING A DUST EXPLOSION.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP MATERIAL AND PACKAGE FOR SAFE FEED TO
AN INCINERATOR. DISPOSE BY INCINERATION OR CONTRACT WITH LICENSED
CHEMICAL WASTE DISPOSAL AGENCY.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP FROM CNTCT W/OXIDIZING MATLS.
POTENTIALLY HEAT SENSITIVE. EXERCISE CAUTION IF HEATING IN A CLSD
VESSEL. STORE IN COOL PLACE. KEEP AWAY FROM FIRE.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:A NIOSH/MSHA APPROVED POSITIVE PRESSURE AIR
SUPPLIED RESPIRATOR SHOULD BE WORN, IF NEEDED.
Ventilation:GOOD GENERAL ROOM VENTILATION SHOULD BE USED. LOCAL EXHAUST
VENTILATION OR AN ENCLOSED HANDLING SYSTEM MAY BE (SUPDAT)
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
% VOLAT: (WT) NEGLIGIBLE. VENT: NECESSARY TO CONTROL VAPOR
CONCENTRATION TO ACCEPTABLE LEVELS.
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:95.0F,35.0C
Vapor Pres:NEGLIGIBLE
Spec Gravity:NOT AVAILABLE
Evaporation Rate & Reference:NEGLIGIBLE (N-BUAC=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:WHITE SOLID
Percent Volatiles by Volume:SUPDAT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:NO
STRONG OXIDIZERS.
Stability Condition to Avoid:STABILITY NOT FULLY EVALUATED. MATERIALS
CONTAINING SIMILAR FUNCTIONAL GROUPS CAN VIOLENTLY DECOMPOSE AT
ELEVATED TEMPS.
Hazardous Decomposition Products:COMBUSTION WILL PRODUCE CARBON DIOXIDE
AND PROBABLY CARBON MONOXIDE. OXIDES OF NITROGEN MAY ALSO BE
PRESENT.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT, OR DISPOSAL MAY BE SUBJECT
TO FEDERAL, STATE OR LOCAL LAWS.
| 1 | gloves_mandatory |
Subsets and Splits
No community queries yet
The top public SQL queries from the community will appear here once available.