text
stringlengths 789
11.3k
| label
int64 0
1
| label_text
stringclasses 2
values |
|---|---|---|
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL AND GENERAL VENTILATION NECESSARY TO KEEP AIR
CONCENTRATION BELOW LEVEL OF CONCERN .
Other Protective Equipment:NONE
Work Hygienic Practices:N/K
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:THIS MATERIAL CONTAINS NO INGREDIENTS AT >1% AS DEFINED BY
FEDERAL AND STATE RIGHT-TO-KNOW LAWS (MFR).
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SEE SIGNS AND SYMPTOMS OF
OVEREXPOSURE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:NO ADVERSE EFFECTS EXPECTED.EYES:DIRECT CONTACT
MAY CAUSE SOME IRRITATION.SKIN/INGESTION/INHALATION:N/K .
Medical Cond Aggravated by Exposure:N/K
* First Aid Measures *
First Aid:EYES:FLUSH IMMEDIATELY WITH PLENTY OF COOL WATER FOR AT LEAST
MD.SKIN:N/A.INGESTION:CONTACT MD FOR ADVICE.NO ADVERSE EFFECTS
EXPECTED.INHALATION :REMOVE TO FRESH AIR.SUPPORT BREATHING (GIVE
O*2/ARTIFICIAL RESPIRATION) .
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:N/K
Upper Limits:N/K
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
Spill Release Procedures:FLUSH TO DRAIN.
Neutralizing Agent:N/K
*Handling and Storage *
Handling and Storage Precautions:KEEP FROM FREEZING.DO NOT REUSE EMPTY
BOTTLES FOR ANY OTHER PURPOSE.
Other Precautions:READ & FOLLOW ALL LABEL DIRECTIONS AND PRECAUTIONS
BEFORE USE.THESE PRODUCTS ARE INTENDED FOR INDUSTRIAL USE ONLY.KEEP
OUT OF THE REACH OF CHILDREN.
* Physical/Chemical Properties *
Melt/Freeze Pt:M.P/F.P Text:N/K
Decomp Temp:Decomp Text:N/K
Vapor Pres:N/K
Vapor Density:N/K
pH:SUP DA
Evaporation Rate & Reference:N/K
Solubility in Water:COMPLETE
Appearance and Odor:A CLEAR OPAL GREEN LIQUID WITH PLEASANT LOW LEVEL
FRAGRANCE.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:N/K
Hazardous Decomposition Products:NONE
Conditions to Avoid Polymerization:WILL NOT OCCUR.
* Disposal Considerations *
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH
FEDERAL,STATE AND LOCAL REGULATIONS .THIS IS NOT A HAZARDOUS WASTE.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE INDICATED BY MFR.
Ventilation:LOCAL EXHAUST: MAINTAIN ADEQUATE VENTILATION.
Supplemental Safety and Health
FOR PAT B DATA UNDER THIS NSN; PH OF SOLN:5.0 T 7.0; PER MFR,
* Product Identification *
Product ID:CRONALITH LITHO DEVELOPER, CLLD, PART A
* Composition/Information on Ingredients *
Ingred Name:HYDROQUINONE (SARA III)
OSHA PEL:2 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:GLYCOL SOLUTION
Fraction by Wt: UNK
Ingred Name:AQUEOUS SOLUTION,HAZARD UNKNOWN,UNIDENTIFIED
Fraction by Wt: UNK
* Hazards Identification *
Effects of Overexposure:CAUSES EYE & SKIN IRRITATION.
* First Aid Measures *
First Aid:INHALE:REMOVE TO FRESH AIR, GIVE CPR/O*2 IF
GET MEDICAL ATTENTION FOR EYES, BREATHING DIFFICULTY, OR OTHER
SYMPTOMS OF OVEREXPOSURE;I F INGESTED,CALL PHYSICIAN.
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:CO*2, FOAM, DRY CHEM.
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
Spill Release Procedures:ELIMINATE IGNITION SOURCES. STOP LEAK.
EVACUATE AREA.DO NOT TOUCH SPILLAGE. SM SPILL:ABSORB W. INERT
ABSORBENT. PLACE IN CLOSED CONTAINER. FLUSH AREA W. WATER. LG
SPILL: DIKE AHEAD FOR LATER DISPOSAL. NOTIFY AUTHORITIES;FLUSH TO
CHEM SEWERW/H*2O.
*Handling and Storage *
Handling and Storage Precautions:STORE IN COOL,DRY,WELL VENTILATED
AREA. PROTECT FROM PHYSICAL DAMAGE.AVOID ANY PHYSICAL CONTACT. KEEP
CONTAINERS TIGHTLY CLOSED
Other Precautions:AVOID CONTACT W/SKIN,EYES & CLOTHING.WASH THOROUGHLY
AFTER HANDLING.WASH CLOTHES BEFORE REUSE.KEEP FROM THE REACH OF
CHILDREN;DO NOT TAKE INTERNALLY.
* Physical/Chemical Properties *
HCC:N1
Vapor Pres:UNK
Vapor Density:UNK
Solubility in Water:COMPLETE
Appearance and Odor:LIGHT AMBER CLEAR LIQUID
Percent Volatiles by Volume:UNK
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:NONE KNOWN
* Disposal Considerations *
Waste Disposal Methods:KEEP IN COVERED DRUMS,PENDING DISPOSAL. HANDLE &
DISPOSE IN FULL COMPLIANCE WITH ALL APPLICABLE
INTERNATIONAL,FEDERAL,STATE, & LOCAL REGULATIONS;MFR NOTES,FLUSH TO
CHEMICAL OR INDUSTRIAL PROCESS SEWER .
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE A PROPERLY FITTED NIOSH/MSHA APPROVED
MECHANICAL RESPIRATOR OR MASK TO AVOID BREATHING DUST.
Ventilation:SUFFICIENT VENTILATION IN VOLUME & PATTERN TO KEEP AIR
CONTAM CONCENTRATIONS BELOW OSHA EXPOSURE LEVELS OR TLV LIMITS.
Other Protective Equipment:PROTECTIVE OVERALLS RECOMMENDED.
Work Hygienic Practices:REMOVE AND WASH SOILED CLOTHES.
Supplemental Safety and Health
NK
* Product Identification *
Product ID:BLUE STREAK
* Composition/Information on Ingredients *
Ingred Name:CALCIUM CARBONATE
Other REC Limits:NONE RECOMMENDED
Ingred Name:1,3,5-TRIGLYCIDYL ISOCYANURATE
Fraction by Wt: 3-7%
Other REC Limits:NONE RECOMMENDED
Fraction by Wt: 0.5-1.5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:TITANIUM DIOXIDE
Fraction by Wt: 0.5-1.5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:NUISANCE DUST
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: IRRIT. SKIN: IRRIT. INHAL:
RESPIRATORY TRACT IRRIT, NOSEBLEEDS. INGEST: MILDLY TOXIC, LOSS OF
APPETITE, NOSEBLEEDING.
Medical Cond Aggravated by Exposure:RESPIRATORY ILLNESS AND DERMATITIS
MAY BE AGGRAVATED BY EXCESSIVE EXPOSURE.
* First Aid Measures *
AID. SKIN: WASH W/SOAP & WATER. INHAL: REMOVE TO FRESH AIR. INGEST:
DRI 1-2 GLASSES OF WATER. INDUCE VOMIT BY STICKING FINGER DOWN
THROA T. GET MED AID.
* Fire Fighting Measures *
Extinguishing Media:FOAM, CO2, DRY CHEMICAL, WATER FOG, DRY SAND.
Fire Fighting Procedures:USE FULLY PROTECTIVE EQUIPMENT W/SCBA.
* Accidental Release Measures *
Spill Release Procedures:SWEEP UP CAREFULLY OR USE EXPLOSION-PROOF
VACUUM CLEANER.
*Handling and Storage *
Handling and Storage Precautions:KEEP EQUIPMENT CLEAN AND GROUNDED TO
AVOID STATIC ELECTRICITY DISCHARGE. KEEP WORK AREAS FREE OF DUST.
KEEP OUT OF REACH OF CHILDREN.
Other Precautions:KEEP CONTAINERS SEALED AND AVOID STATIC ELECTRICITY
DISCHARGES.
* Physical/Chemical Properties *
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:CO, CO2, NO2, AND OTHER NITROGEN
COMPOUNDS.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/FEDERAL, STATE AND
LOCAL REGULATIONS.
*
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR FOR LEAD, IF
EXPOSURES EXCEED THE OSHA LIMIT. HEPA FILTERS MAY BE NEEDED FOR
GENERAL VENTILATION.
Ventilation:USE ENOUGH VENTILATION WHEN CUTTING OR GRINDING TO KEEP THE
DUST AND FUMES FROM THE WORKERS BREATHING ZONE & BELOW PEL.
Other Protective Equipment:SAFETY EYEWASH STATION
Work Hygienic Practices:WASH THOROUGHLY BEFORE EATING OR SMOKING.
LAUNDER CONTAMINATIED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
THERE IS DANGER OF SPLASHING MOLTEN METAL.MANUFACTURER RECOMMENDS
USE OF A LOCALIZED FUME HOOD OVER WORK AREA. DO NOT USE DRY
SWEEPING OR COMPRESSED AIR CLEANING SYSTEMS.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:TIN
Other REC Limits:NONE SPECIFIED
OSHA PEL:2 MG/M3
Ingred Name:LEAD (SARA III)
Fraction by Wt: 0.2%
Other REC Limits:NONE SPECIFIED
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:ANTIMONY (SARA III)
Fraction by Wt: 6.0%
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.5 MG/M3
Ingred Name:CADMIUM (SARA III)
Other REC Limits:NONE SPECIFIED
Ingred Name:COPPER (SARA III)
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.1MG/M3 FUME/1 DUST
Ingred Name:ARSENIC (SARA III)
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.5 MG/M3 (AS)
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:IRON
Other REC Limits:NONE SPECIFIED
Ingred Name:ALUMINUM (SARA III)
Other REC Limits:NONE SPECIFIED
Ingred Name:ZINC (SARA III)
Other REC Limits:NONE SPECIFIED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: WHILE IT IS POSSIBLE FOR LEAD
TAKEN IN EXTREMELY LARGE DOSES TO CAUSE ENCEPHALOPATHY, A BRAIN
CONDITION THAT CAN RESULT IN SEIZURES, COMA AND DEATH, EXPOSURES OF
THIS MAGNITUDE ARE HIGHLY UNUSU AL. CHRONIC: MAY RESULT IN DAMAGE
TO THE BLOOD-FORMING, NERVOUS, URINARY AND REPRODUCTIVE SYSTEMS.
Explanation of Carcinogenicity:NOT LISTED BY NTP,IARC OR OSHA AS A
CARCINOGEN. ARSENIC IS KNOWN TO BE CARCINOGENIC AND MAY BE PRESENT
IN TRACE AMOUNTS.
Effects of Overexposure:LOSS OF APPETITE, METALLIC TASTE IN THE MOUTH,
ANXIETY, CONSTIPATION, NAUSEA, PALLOR, EXCESSIVE TIREDNESS,
WEAKNESS, INSOMNIA, HEADACHE, NERVOUS IRRITABILITY, MUSCLE AND
JOINT SORENESS, TREMORS, DIZZI NESS, ABDOMINAL PAIN, JOINT
PAIN/WEAKNESS, WEIGHT LOSS,LEAD LINE ON GUMS, MENTAL CONFUSION.
Medical Cond Aggravated by Exposure:DISEASES OF THE BLOOD-FORMING,
NERVOUS, URINARY AND REPRODUCTIVE SYSTEMS. EXPOSURE TO LEAD MAY
RESULT IN INJURY TO A DEVELOPING FETUS. WOMEN OF CHILD BEARING AGE
SHOULD AVOID EXPOSURE TO LEAD.
* First Aid Measures *
First Aid:IF A PERSON BREATHES IN A LARGE AMOUNT OF DUST OR FUMES,
REMOVE FROM EXPOSURE. IF BREATHING HAS STOPPED, PERFORM ARTIFICIAL
RESPIRATION. CALL A PHYSICIAN. IF LEAD HAS BEEN INGESTED, INDUCE
VOMITING IF THE INDIVIDUAL IS CONSCIOUS. CALL A PHYSICIAN. IF LEAD
GETS IN EYES, FLUSH WITH A LARGE AMOUNT OF WATER. CALL A PHYSICIAN.
TREAT MOLTEN METAL BURNS AS ORDINARY BURN FIRST AID.
* Fire Fighting Measures *
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL AS APPROPRIATE FOR SURROUNDINGS.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY CAUSE
PRODUCTION OF HAZARDOUS DECOMPOSITION PRODUCTS. LEAD AND OTHER
HEAVY METAL FUMES MAY BE EVOLVED AT HIGH TEMPERATURES.
* Accidental Release Measures *
Spill Release Procedures:CLEAN UP BY VACUUMING TO MINIMIZE DUST
EXPOSURE. PROVIDE CLEAN UP EMPLOYEES WITH RESPIRATORS IF THE
POSSIBILITY FOR EXPOSURE TO DUST OR FUMES EXISTS.
*Handling and Storage *
Handling and Storage Precautions:PRACTICE GOOD HOUSEKEEPING TO PREVENT
ACCUMULATION OF DUST. DO NOT SMOKE OR EXPOSE FOOD OR DRINK TO DUST.
WASH HANDS AFTER HANDLING.
EXPOSURE CONTROL.
* Physical/Chemical Properties *
HCC:N1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:GREY SOLID, ODORLESS
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Hazardous Decomposition Products:LEAD OXIDE AND ANTIMONY OXIDE FUMES
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE &
LOCAL LAWS AND REGULATIONS. SCRAP DRIPPINGS AND DROSSES SHOULD BE
KEPT IN A CLOSED CONTAINER AND RETURNED TO AN APPROPRIATE METAL
RECYCLER.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:AS REQUIRED
Ventilation:GENERAL MECHANICAL IF GROUND, HOT-STAKED OR SOLDERED. LOCAL
EXHAUST FOR GRINDING, BURINING & MOLTEN CONDITIONS.
Supplemental Safety and Health
UNDER SOME SOLDERING, HOT-STAKING OR OTHER VERY HIGH TEMPERATURE
CONDITIONS, TOLUENEDI-ISOCYANATE (TDI) OR OTHER ISOCYANATE
FRACTIONS MAY BE GIVEN OFF.
* Product Identification *
Product ID:COPPER-BASED,FILM-INSULATED MAGNET WIRE
Preparer's Name:FRANCOIS A LAVALLEE
* Composition/Information on Ingredients *
Ingred Name:COPPER (DUST & MIST), BRONZE POWDER
Other REC Limits:1 MG(CU)/M3 (DUST)
OSHA PEL:0.1 MG(CU)/M3 (FUME)
ACGIH TLV:0.2 MG/M3 (FUME)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: RESPIRATORY TRACT
IRRITATION, METALLIC TASTE IN MOUTH, NAUSEA. SKIN: DISCOLORATION,
SENSITIZATION, MUCOUS MEMBRANES IRRITATION. EYES: IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: METAL FUME FEVER.
* First Aid Measures *
First Aid:SKIN: WASH W/SOAP & WATER. EYES: FLUSH W/PLENTY OF WATER.
INHALATION: REMOVE TO FRESH AIR. SEEK MEDICAL ATTENTION IN ALL
CASES.
* Fire Fighting Measures *
Extinguishing Media:COMPATIBLE W/ALL TYPES (A,B,C). AVOID WATER ON
MOLTEN METAL.
Fire Fighting Procedures:MATCH THE TECHNIQUE TO THE TYPE OF FIRE.
Unusual Fire/Explosion Hazard:CONTACT OF WATER W/MOLTEN COPPER CAN
CAUSE EXPLOSION.
* Physical/Chemical Properties *
Vapor Pres:<1
Evaporation Rate & Reference:NOT MEASURABLE
Solubility in Water:INSOLUBLE
Appearance and Odor:AMBER OR COLORED SOLID, W/NO ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
CONCENTRATED ACIDS & BASES. BARE CONDUCTOR SHOULD NOT CONTACT ACETYLENE
GAS OR MAGNESIUM.
Stability Condition to Avoid:HIGH TEMPERATURES
Hazardous Decomposition Products:H2O, CO, CO2, OXIDES OF NITROGEN &
COMPONENT INGREDIENTS. TOLUENEDI-ISOCYANATE OR OTHER ISOCYANATE
FRACTIONS.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS. RECYCLE CONDUCTOR, OR SUITABLE LANDFILL.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:RESPIRATOR WILL NOT NORMALLY BE NECESSARY. USE
NIOSH/MSHA APPROVED RESPIRATOR FOR ORGANIC DUST/MIST IF EXPOSURE IS
TO RESPIRATOR USE.
Ventilation:NORMAL VENTILATION IS USUALLY SUFFICIENT. SUPPLEMENT WITH
LOCAL EXHAUST IF PEL/TLV IS EXCEEDED.
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER. AVOID
PROLONGED AND/OR REPEATED CONTACT BY USING APPROPRIATE CLOTHING.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. AVOID ANY UNNECESSARY CONTACT.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:PROPYLENE GLYCOL METHYL ETHER ACETATE
Other REC Limits:NONE SPECIFIED
Ingred Name:PROPRIETARY ADDITIVES
Other REC Limits:NONE SPECIFIED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PRODUCT CAUSES MILD IRRITATION OF BODY
TISSUES. IT DEPRESSES THE CENTRAL NERVOUS SYSTEM AND MAY CAUSE
KIDNEY AND LIVER DAMAGE. IT MAY BE FATAL IF INGESTED.
Explanation of Carcinogenicity:NONE OF THE COMPOUNDS IN THIS PRODUCT IS
LISTED BY IARC, NTP, OR OSHA AS A CARCINOGEN.
Effects of Overexposure:EYE:SEVERE IRRITATION POSSIBLE CORNEAL DAMAGE.
SKIN:MILD IRRITATION,IT MAY SENSITIZE ACUTE ALLERGIC DERMATITIS.
INHALED:RESPIRATIORY IRRITATION, CENTRAL NERVOUS SYSTEM DEPRESSION.
INGESTED:G/I IRRITA TION AND DISTRESS. LOW SINGLE DOSE TOXICITY.IT
MAY CAUSE LIVER AND/OR KIDNEY DAMAGE.
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF KIDNEY OR
LIVER DISORDERS MAYBE AT INCREASED RISK FROM EXPOSURE.
* First Aid Measures *
SOAP & WATER. REMOVE CONTAMINATED CLOTHING AND LAUNDER BEFORE
REUSE. INHALED:REMOVE TO FRESH AIR. RESTORE BREATHING IF
NECESSARY.INGESTED:D O NOT INDUCE VOMITING. GIVE 2 LARGE GLASSES
OF MILK OR WATER AND GET IMMEDIATE MEDICAL CARE. GIVE NOTHING BY
MOUTH IF UNCONSCIOUS. IF IRRITATION PERSISTS OR IS SEVERE,SEE A
DOCTOR.
* Fire Fighting Measures *
Lower Limits:1.5
Upper Limits:7.0
Extinguishing Media:USE CARBON DIOXIDE, FOAM, OR DRY CHEMICAL. (NFPA
CLASS B)
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:WATER MAY BE INEFFECTIVE IN FIGHTING
FIRE. FIRE OR EXCESSIVE HEAT MAY CAUSE PRODUCTION OF HAZARDOUS
DECOMPOSITION PRODUCTS. CLOSED CONTAINERS MAY RUPTURE.
* Accidental Release Measures *
Spill Release Procedures:ELIMINATE SOURCES OF IGNITION & VENTILATE
AREA. WIPE/SOAK UP WITH PAPER TOWEL OR INERT ABSORBENT. PUT IN
DISPOSAL CONTAINER. FLUSH RESIDUE WITH WATER. LARGE SPILL:
VENTILATE AREA. IF POSSIBLE, STOP LE AK. DIKE TO RETAIN RUN OFF.
VACUUM UP FREE LIQUID.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER. WATER DILUTION
RECOMMENDED.
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL, DRY, WELL VENTILATED
AREA. KEEP CONTAINERS TIGHTLY CLOSED WHEN NOT IN USE. PROTECT
CONTAINERS FROM PHYSICAL DAMAGE.
Other Precautions:NONE
* Physical/Chemical Properties *
HCC:F4
Vapor Pres:3.7 MM
Vapor Density:>1
Evaporation Rate & Reference:<1 (BUTYL ACETATE = 1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR LIQUID, ESTER LIKE ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:NO INFORMATION GIVEN BY MANUFACTURER
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE AND
SILICON OXIDES.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE I/A/W ALL FEDERAL, STATE AND LOCAL
REGULATIONS. DGSC-SSH SUGGESTS THAT DISPOSAL MAY BE DONE BY
INCINERATION.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:REQUIRED IF TLVS ARE EXCEEDED.
Ventilation:LOCAL EXHAUST
Supplemental Safety and Health
* Product Identification *
Product ID:IPS EMPRESS CONTROL PASTE
Preparer's Name:LLOYD ZIEMENDORF
CAGE:0T2N6
CAGE:0T2N6
* Composition/Information on Ingredients *
Ingred Name:METHYLCHLOROFORM (1,1,1-TRICHLOROETHANE) (CHLOROTHENE NU),
Ozone Depleting Chemical:1
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:BURNS OF MOUTH, THROAT & DIGESTIVE
TRACT, PROFOUND TISSUE DAMAGE, IRRITATION TO MUCOUS MEMBRANES,
NOSE, EYES & THROAT, CONJUCTIVITIS, OPAQUENESS OF CORNEA.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:BURNS, IRRITATION, WATERING, LOSS OF SIGHT.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. GIVE CPR/OXYGEN IF NEEDED.
MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Flash Point:-9.4F
Lower Limits:1.2
Upper Limits:7.5
Extinguishing Media:FOAM, CO2, DRY CHEMICAL
* Accidental Release Measures *
Spill Release Procedures:COLLECT ON INERT ABSORBENT. STORE IN CLOSED
CONTAINER FOR PROPER DISPOSAL.
*Handling and Storage *
Handling and Storage Precautions:STORE IN COOL, DRY AREA. KEEP ALL
CONTAINERS CLOSED.
Other Precautions:DON'T INGEST/ALLOW EYE CONTACT. FOR PROFESSIONAL
DENTAL USE ONLY.
* Physical/Chemical Properties *
Appearance and Odor:BLUE PASTE W/NO ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING & REDUCING AGENTS.
Stability Condition to Avoid:HEAT
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:PROVIDE MAXIMUM VENTILATION TO CLEAR OUT HAZARDOUS GASES.
Other Protective Equipment:IMPERVIOUS CLOTHING.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
CNDTNS TO AVOID:SEAL REMAINS INTACT. HNDLG/STOR PREC:BATTERY. FOR
* Product Identification *
Product ID:LITHIUM SULFUR DIOXIDE BATTERY
* Composition/Information on Ingredients *
Ingred Name:LITHIUM (METAL)
Fraction by Wt: <2.5%
OSHA PEL:N/K
ACGIH TLV:N/K
OSHA PEL:5 PPM
ACGIH TLV:2 PPM/5 STEL
Fraction by Wt: <6%
Ingred Name:CARBON BLACK; (ACETYLENE BLACK)
Fraction by Wt: <5%
OSHA PEL:3.5 PPM (MFR)
ACGIH TLV:3.5 PPM (MFR)
Ingred Name:SUPDAT:OTHER MATLS. AIR-CONDITIONING OR COOLING IS NOT REQD
UNLESS EXCESSIVELY HIGH TEMP WILL BE ENCOUNTERED, (ING 6)
Ingred Name:ING 5:BUT BATTERIES SHOULD BE KEPT AS COOL AS POSS IN ORDER
Ingred Name:ING 6:AVOIDED. HERMETICALLY SEALED LITHIUM CELLS DO NOT
OUTGAS. HOWEVER, IF EXPOSED TO EXTREME TEMP/ROUGH HNDLG, (ING 8)
Ingred Name:ING 7:THEY MAY RELEASE SULFUR DIOXIDE GAS IF VENT IS
ACTIVATED/BATTERY DMGD. WELL-VENTILATED STOR AREA SHOULD (ING 9)
Ingred Name:ING 8:BE USED TO PVNT INADVERTENT CONC OF GAS IF EXTREMES
Ingred Name:ING 9:MAY BE ADVISABLE TO INSTALL ALARM DEVICES IN STOR
AREA TO DETECT SMOKE/ACCUMULATION OF GASES.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:DEPENDING ON CONCENTRATION OF SULFUR
DIOXIDE EXPOSURE, IT ACTS AS AN ASPHYXIANT AND MAY POSSIBLY CAUSE
UNCONSCIOUSNESS WITH NO KNOWN CHRONIC HEALTH EFFECTS. SULFUR
DIOXIDE:IRRITATION OF NOSE, THROAT, EYES, AND/OR SKIN; SUFFOCATING
ODOR.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:SULFUR DIOXIDE - ASTHMA AND OTHER
RESPIRATORY DISEASES.
* First Aid Measures *
MINUTES, SEEK ASSISTANCE FROM MD . SKIN:FLUSH W/COPIOUS AMTS OF
WATER. CALL MD. . INHAL:REMOVE PERSON FROM CONTAMD AREA TO FRESH AI
R. INGEST:DRINK 2 GLASSES OF WATER TO DILUTE. IF CELL VENTS, PERS
SHOULD BE EVACUATED FROM CONTAMD AREAS. ARTF RESP SHOULD BE GIVEN
IF BREATHING STOPS.
* Fire Fighting Measures *
Flash Point:NONFLAMMABLE
Extinguishing Media:WATER/CO*2 ON BURNING LITHIUM SULFUR DIOXIDE
CELLS/BATTERIES. USE CLASS D FIRE EXTING AGENT ONLY ON RAW LITHIUM
FIRE.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:BATTERY MAY VENT WHEN SUBJECT TO
EXCESSIVE HEAT-EXPOSING CELL CONTENTS.
* Accidental Release Measures *
Spill Release Procedures:KEEP OUT OF AREA UNLESS USING IMPERVIOUS
VENT TO CLEAR OUT HAZARDOUS GASES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:DO NOT REMOVE OR BYPASS ELECTRICAL OR
Other Precautions:LI/SO*2 CELL IS CAPABLE OF LONG TERM STOR @ TEMP AS
@ LOWER TEMP WILL IM PROVE CAPACITY RETENTION OF (SUPDAT)
CELLS & BATTERIES SHOULD BE STORED IN WELL-VENT, SPRINKLER-PROTECTE
D, NON-COMBUST STRUCTURE W/ADEQ CLEARANCE BETWEEN WALLS & BATTERY
STACKS. BATTERIES SHOULD BE SEPARATED FROM (ING 5)
* Physical/Chemical Properties *
Spec Gravity:>1 (H*2O=1)
Solubility in Water:NOT SOLUBLE IN WATER
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:BATTERY CONTAINS HERMETICALLY SEALED CELLS
& IS NONREACTIVE PROVIDED BATTERY INTEGRITY IS MAINTAINED & CELL
(SUPDAT)
Conditions to Avoid Polymerization:HEATING, MECH ABUSE, & ELEC ABUSE
(SUCH AS RECHARGING, VOLTAGE REVERSAL & SHORT CIRCUITING) MAY RSLT
IN VENTING.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE, AND
FEDERAL ENVIRONMENTAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WAER APPROPRIATE NIOSH/MSHA-APPROVED RESPIRATOR.
Ventilation:USE ONLY IN A CHEMICAL FUME HOOD.
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
IMPERVIOUS BOOTS, APRON, OR COVERALLS AS REQUIRED.
Work Hygienic Practices:DLA-HMIS: OBSERVE GOOD PERSONAL HYGIENE
PRACTICES AND RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED
CLOTHING OR FOOTWEAR.
Supplemental Safety and Health
AVOID PROLONGED OR REPEATED EXPOSURE. DO NOT GET ON SKIN OR IN EYES. DO
NOT BREATHE VAPORS OR MISTS. PROTECT FROM MOISTURE. LARGE AMOUNT OF
HEAT GENERATED ON CONTACT WITH WATER. PRODUCT WILL ATTACK G LASS,
CONCRETE, CERTAIN METALS. IT MUSTBE SHIPPED AND STORED IN PRESSURE
CONTAINERS DUE TO ITS LOW BOILING POINT.
* Product Identification *
CAGE:1GKT4
CAGE:1GKT4
CAGE:1GKT4
* Composition/Information on Ingredients *
Ingred Name:HYDROGEN FLUORIDE (SARA III) OR HYDROFLUORIC ACID
OSHA PEL:3 PPM/6 STEL (F)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:-HIGHLY TOXIC BY INGESTION AND
INHALATION. CORROSIVE TO ALL BODY TISSUES, AND CAUSES BURNS ON
CONTACT. WILL PENETRATE SKIN AND ATTACK THE UNDERLING TISSUES AND
BONES. POSSIBLE RISK OF IRRIVERSI BLE EFFECTS. MAY CAUSE PERMANENT
DAMAGETO EYES & LUNGS. TARGET ORGANS: LIVER AND KIDNEY.
CHRONIC:CAUSES CHANGES IN BONES AND JOINTS, POSSIBLE MUTAGEN.
Explanation of Carcinogenicity:NONE SPECIFIED BY MANUFACTURER.
Effects of Overexposure:CORNEAL BURNS; SEVERE SKIN BURNS WITH
ULCERATION; PAIN, COUGH, SPITTING BLOOD, DYSPNEA, DIFFICULT
BREATHING, BRONCHOPNEUMONIA, CYANOSIS, SHOCK, MUSCLE SPASMS,
CONVULSIONS, COMA, NAUSEA, VOMITING, ABDO MINAL PAIN, DIARRHEA;
BURNS AND CORROSION OF MOUTH, ESOPHAGUS, STOMACH.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:IN CASE OF CONTACT, IMMEDIATELY FLUSH EYES OR SKIN WITH
CONTAMINATED CLOTHES & SHOES. ASSURE ADEQUATE FLUSHING OF THE EYES
BY SEPARATING THE EYELIDS WITH FINGERS. IF INHALED, REMOVE TO
FRESH AIR. IF NOT BREATHING GIVE ARTIFICIAL RESPIRATION. IF
BREATHING IS DIFFICULT, GIVE OXYGEN. IF SWALLOWED, WASH OUT MOUTH
WITH WATER PROVIDED PERSO N IS CONSCIOUS. CALL A PHYSICIAN. WASH
CONTAMINATED CLOTHING BEFORE REUSE..
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:DRY CHEMICAL POWDER.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS &
PROTECTIVE CLOTHING TO PREVENT CONTACT WITH SKIN & EYES.
Unusual Fire/Explosion Hazard:EMITS TOXIC FUMES UNDER FIRE CONDITIONS.
CONTAINER EXPLOSION MAY OCCUR UNDER FIRE CONDITIONS.
* Accidental Release Measures *
Spill Release Procedures:EVACUATE AREA. WEAR SELF-CONTAINED BREATHING
VERMICULITE & PLACE IN CLOSED CONTAINERS FOR DISPOSAL. VENTILATE
AREA & WASH SPILL SITE A FTER MATERIAL PICK-UP IS COMPLETE.
Neutralizing Agent:SODA ASH, LIME OR OTHER SUITABLE ALKALINE MATERIAL.
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL, DRY, WELL VENTILATED
AREA. KEEP CONTAINERS TIGHTLY CLOSED WHEN NOT IN USE. DLA-HMIS:
PROTECT CONTAINERS FROM PHYSICAL DAMAGE & DIRECT SUNLIGHT.
Other Precautions:DO NOT TAKE INTERNALLY. DO NOT BREATHE MIST. AVOID
PROLONGED OR REPEATED BREATHING OF VAPOR. AVOID CONTACT WITH EYES.
USE WITH ADEQUATE VENTILATION. WASH THOROUGHLY AFTER HANDLING. USE
ONLY IN A CHEMI CAL FUME HOOD.
* Physical/Chemical Properties *
HCC:C1
Evaporation Rate & Reference:<1.0(N-BUTYL ACETATE = 1)
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS LIQUID
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ALKALIES, GLASS, CERAMICS, METALS, ALKALI METALS.
Stability Condition to Avoid:STORE AWAY FROM HEAT & DIRECT SUNLIGHT.
Hazardous Decomposition Products:HYDROGEN FLUORIDE.
Conditions to Avoid Polymerization:DLA-HMIS: WILL NOT OCCUR. HOWEVER,
NON-HAZARDOUS ENDOTHERMIC POLYMERIZATION MAY OCCUR IN BOTH THE
LIQUID AND GASEOUS PHASES.
* Toxicological Information*
Toxicological Information:HYDROFLUORIC (HF) REPORTED TO BE EBMRYOTOXIC
PPM/1H .
* Ecological Information *
Ecological:NONE SPECIFIED BY MANUFACTURER.
* Disposal Considerations *
Waste Disposal Methods:NONE SPECIFIED BY MANUFACTURER.DLA-HMIS:
DISPOSAL SHOULD BE MADE IN ACCORDANCE WITH ALL APPLICABLE FEDERAL,
STATE AND LOCAL LAWS AND REGULATIONS. DISPOSE IN A RCRA-APPROVED
WASTE FACILITY OR SEWER T HE NEUTRALIZED SLURRY WITH EXCESS WATERIF
LOCAL ORDINANCES ALLOW.
* MSDS Transport Information *
* Regulatory Information *
SARA Title III Information:DLA-HMIS: THIS PRODUCT IS SUBJECT TO SARA
State Regulatory Information:NONE SPECIFIED BY MANUFACTURER.
* Other Information *
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE REQUIRED WITH ADEQUATE VENTILATION. USE
NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN
.
Ventilation:USE ADEQUATE VENTILATION.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH HANDS THORO AFTER EACH USE.
Supplemental Safety and Health
OTHER PREC: BEFORE USING PRODUCT.
* Product Identification *
Product ID:IMPACT, ORGANIC SOLVENT CLEANER
* Composition/Information on Ingredients *
Ingred Name:CYCLOHEXENE,1-METHYL-4-(1-METHYLETHENYL)-, (R)-;
(D-LIMONENE)
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE/CHRONIC: CAN CAUSE SLIGHT TO
MODERATE IRRITATION TO SKIN, EYES, AND RESPIRATORY TRACT. CAN CAUSE
NAUSEA, VOMITING, AND DIARRHEA IF SWALLOWED. OVEREXPOSURE BY INHAL
MAY CAUSE DIZZINESS, HEADACHE, NAUSEA, AND EVEN LOSS OF
CONSCIOUSNESS.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INHAL:MOVE TO FRESH AIR.IF BRTHG HAS STOPPED, ADMINISTER ARTF
RESP. CALL A PHYS. INGEST: DO NOT INDUCE VOMIT. CONT A PHYS IMMED.
MINUTES, L IFTING LIDS OCCAS AND REMOVING ANY CONTACT LENSES. SEEK
MED ATTN. SKIN: FLUSH W/PLENTY OF WATER WHILE REMOVING CONTAMD
* Fire Fighting Measures *
Flash Point Method:TOC
Extinguishing Media:WATER FOG, CO*2, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . DRUMS MAY BUILD PRESSURE AND RUPTURE UNDER
EXTREME HEAT.
Unusual Fire/Explosion Hazard:CONCENTRATED VAPORS CAN BE IGNITED BY
EXTREME HEAT/ANY IGNITION SOURCE. DO NOT CUT/WELD NEAR DRUM.
* Accidental Release Measures *
Spill Release Procedures:CONTAIN LARGE SPILL AND PUMP TO RECOVER. SMALL
SPILLS CAN BE MOPPED UP. DO NOT USE CLAY-TYPE ABSORBENT MATERIALS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE. KEEP CONTR
CLSD WHEN NOT IN USE. KEEP OUT OF REACH OF CHILDREN. WASH HANDS
AFTER USING PROD. COMBUST MATLS.
Other Precautions:DO NOT CONSUME FOOD/BEVERAGE WHILE USING PROD. DO NOT
MIX CHEM UNLESS SPECIFICALLY DIRECTED TO. DO NOT SMOKE WHILE USING
PROD. DO NOT SMOKE IN WORK AREA. PLEASE READ & FOLLOW ALL LBL DIREC
& ANY OTHER SFTY INFO PROVIDED TO YOU (SUPDAT)
* Physical/Chemical Properties *
Vapor Pres:1
Vapor Density:4.7
Evaporation Rate & Reference:<ETHER(BUTYL ACETATE=1)
Solubility in Water:FORMS EMULSION
Appearance and Odor:CLEAR, ORANGE LIQUID, STRONG ORANGE ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ACIDIC AGENTS INCLUDING CLAYS.
Stability Condition to Avoid:SPARKS, FLAMES, HIGH TEMPERATURE.
Hazardous Decomposition Products:CO,K CO*2, AND OTHER POSSIBLE.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF I/A/W ALL FEDERAL, STATE, AND LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE USE NIOSH/MSHA APPROVED SELF-CONTAINED
Ventilation:PROVIDE ADEQUATE DILUTION VENTIALTION TO PREVENT AIR
Other Protective Equipment:OVERALLS OR SIMILAR CLOTHES TO PREVENT
CONTACT OF LIQUID WITH SKIN.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
* Product Identification *
Product ID:NATURAL GAS
Preparer's Name:RICH GUFFEY
CAGE:0CEX1
CAGE:0CEX1
* Composition/Information on Ingredients *
Ingred Name:METHANE
Other REC Limits:NONE RECOMMENDED
Ingred Name:ETHANE
Fraction by Wt: 3.1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:N-BUTANE
Fraction by Wt: 0.2%
Other REC Limits:NONE RECOMMENDED
Ingred Name:PROPANE
Fraction by Wt: 0.8%
Other REC Limits:NONE RECOMMENDED
Ingred Name:ALKYL MERCAPTANS
Other REC Limits:NONE RECOMMENDED
Ingred Name:ISO-BUTANE
Fraction by Wt: 0.2%
Other REC Limits:NONE RECOMMENDED
Ingred Name:ISOPENTANE
Fraction by Wt: 0.1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:N-PENTANE (PENTANE)
Fraction by Wt: 0.1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:CARBON DIOXIDE
Fraction by Wt: 3%
Other REC Limits:NONE RECOMMENDED
Ingred Name:NITROGEN
Fraction by Wt: 2%
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION IS THE MAJOR AND
POSSIBLY ONLY ROUTE OF ENTRY INTO THE BODY. IT IS CONSIDERED A
SIMPLE ASPHYXIANT.SKIN CONTACT WITH LIQUID MAY CAUSE FREEZE
BURNS. CHRONIC: NONE SPECIFIED BY MANUFA CTURER.
Explanation of Carcinogenicity:NO INGREDIENT OF A CONCENTRATION OF 0.1%
OR GREATER IS LISTED AS A CARCINOGEN OR SUSPECTED CARCINOGEN.
Effects of Overexposure:DIZZINESS, CYANOSIS, DIMINISHED MENTAL
CAPACITY, COLLAPSE, LOSS OF CONSCIOUSNESS, AND/OR DEATH. CONTACT
WITH LIQUID CAN PRODUCE FREEZE BURNS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. QUICKLY RESTORE AND/OR
SUPPORT BREATHING AS REQUIRED; GIVE ARTIFICIAL RESPIRATION
IMMEDIATELY. ADMINISTER OXYGEN IF AVAILABLE. SKIN: WARM INJURED
AREA; TREAT AS FROSTB ITE. GET IMMEDIATE MEDICAL ATTENTION.
* Fire Fighting Measures *
Lower Limits:3.6%
Extinguishing Media:CARBON DIOXIDE OR DRY CHEMICAL. STOP FLOW OF GAS
BEFORE EXTINGUISHING.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE GEAR. USE WATER SPRAY TO COOL FIRE EXPOSED
CONTAINERS AND SURROUNDINGS.
Unusual Fire/Explosion Hazard:EXTREMELY FLAMMABLE AND READILY FORMS
EXPLOSIVE MIXTURES WITH AIR. IN PRESENCE OF CATALYST OR SOURCES OF
IGNITION, VIOLENT OR EXPLOSIVE REACTIONS W/OXIDIZERS.
* Accidental Release Measures *
Spill Release Procedures:NOTIFY SAFETY PERSONNEL; EVACUATE AREA.
VENTILATE AREA. ELIMINATE ALL SOURCES OF IGNITION. SHUT OF LEAK.
TEST ATMOSPHERE PRIOR TO ENTRY. CHECK FOR LEAKS USING SOAPY WATER.
WEAR PROPER RESPIRATORY PROT ECTION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:GROUND ALL LINES AND EQUIPMENT USED
AROUND OR ON NATURAL GAS TO PREVENT SPARKS. USE NON-SPARKING
TOLLS. NO SMOKING.
* Physical/Chemical Properties *
HCC:G2
Vapor Density:0.6(AIR=1)
Appearance and Odor:COLORLESS, ODORLESS GAS UNLESS MERCAPTAN ADDED;
THEN SMELLS OF ROTTEN CABBAGE
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZERS, AIR, HALOGENS
Stability Condition to Avoid:EXPOSURE TO HEAT, FLAME, OXIDIZERS,
HALOGENS AND AIR.
Hazardous Decomposition Products:BROMINE PENTAFLUORIDE, CHLORINE,
CHLORINE DIOXIDE, NITROGEN TRIFLUORIDE, OXYGEN DIFLUORIDE, LIQUID
OXYGEN.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NOT NORMALLY NECESSARY, BUT PRODUCT SHOULD BE
USED IN AREAS OF GOOD VENTILATION.
Ventilation:LOCAL EXHAUST: YES.
Work Hygienic Practices:WASH HANDS THOROUGHLY AFTER USE.
Supplemental Safety and Health
* Product Identification *
Product ID:ANAEROBIC ADHESIVE/SEALANT
Preparer's Name:ENVIRONMENTAL HLTH & SFTY
* Composition/Information on Ingredients *
Ingred Name:"NOT HAZARDOUS"
Other REC Limits:NONE SPECIFIED
* Hazards Identification *
Health Hazards Acute and Chronic:ORGANIC PEROXIDE HAS BEEN REPORTED TO
CAUSE TUMORS IN EXPERIMENTAL ANIMALS WHEN INJECTED UNDER THE SKIN.
LOW CONCENTRATIONS (<5%) CONTAINED IN PRODUCT SHOULD PRESENT NO
DANGER WHEN USED IN NORMAL COND ITIONS.
Explanation of Carcinogenicity:SACCHARIN REPORTED TO CAUSE TUMORS IN
ANIMALS.CONCENTRATIONS IN PRODUCT <1%, SHOULD PRESENT NO DANGER IN
NORMAL CONDITNS
Effects of Overexposure:PROLONGED SKIN CONTACT MAY CAUSE DERMATIITS IN
SENSITIVE INDIVIDUALS.
* First Aid Measures *
First Aid:SKIN AND EYE CONTACT: FLUSH WITH WATER. INGESTION: KEEP CALM,
REMOVE TO FRESH AIR. DO NOT INDUCE VOMITING. OBTAIN MEDICAL
ASSISTANCE.
* Fire Fighting Measures *
Flash Point Method:TCC
Extinguishing Media:CO2, FOAM, DRY CHEMICALS
Fire Fighting Procedures:AIR MASK AND PROCEDURES FOR FIGHTING CHEMICAL
FIRES
Unusual Fire/Explosion Hazard:CONTAINS ORGANIC PEROXIDE
* Accidental Release Measures *
Spill Release Procedures:PROVIDE GOOD VENTILATION. AVOID EYE AND SKIN
CONTACT. SOAK UP SPILL WITH EARTH, SAND, OR ABSORBENT PRODUCT
(ZORBAL). RECOVER IN CONTAINER.
*Handling and Storage *
LIFE. STORE IN ORIGINAL CONTAINER.
Other Precautions:AVOID PROLONGED SKIN CONTACT.
* Physical/Chemical Properties *
HCC:N1
Spec Gravity:1.1
Solubility in Water:PARTIAL
Appearance and Odor:BROWN LIQUID, LOW ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZING AND REDUCING AGENTS
Hazardous Decomposition Products:CO, CO2, NITROUS OXIDES
* Disposal Considerations *
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH STATE, FEDERAL, AND
LOCAL ANTI-POLLUTION AND WASTE DISPOSAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE GENERALLY NEEDED UNDER ORDINARY LAB
CONDITIONS. WHERE AIR CONTAMINANTS EXCEED ACCEPTABLE LEVELS, USE
NIOSH APPRVD FULL FACE RESPIRATORY PROTECTION EQUIPMENT.
Ventilation:LOCAL EXHAUST AND CHEMICAL FUME HOODS.
Other Protective Equipment:RUBBER APRON, CHEMICAL RESISTANT BOOTS, LAB
COAT. ANSI APPRVD EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
PH:5.8-6.2. MATLS TO AVOID:ACIDS AND AMMONIA. EXPLAN OF CARCIN:BE
CARCIN. ANIMAL:NASAL TUMORS. EFTS OF OVEREXP:FORMALDEHYDE; POTNTL
NASAL CANCERS. CAN CAUSE DERM & ASTHMA.METHANOL; PRLNGD EXPOS MAY
CAUSE REPROD, LUNG, LIVER, KIDNEY DISORDER (ING 4)
* Product Identification *
Preparer's Name:MARCIA D WELCH
CAGE:NEWCX
CAGE:NEWCX
* Composition/Information on Ingredients *
Fraction by Wt: 3.7%
ACGIH TLV:C 0.3 PPM, A2
OSHA PEL:S, 5 PPM
ACGIH TLV:S, 5 PPM
Fraction by Wt: 1.0%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPDAT:(ANIMAL DATA). MAY CAUSE BLINDESS & DEATH IF
INGESTED. PHENOL; INHAL MAY CAUSE DMG TO MEMB, DIGESTIVE, (ING 5)
Ingred Name:ING 4:NERVOUS & SKIN DISORDER. INGEST CAN CAUSE SYSTEMIC
DAMAGE LEADING TO DEATH.
Ingred Name:FIRST AID PROC:IMMED CONT POIS CTL CTR/HOSPITAL EMER ROOM
FOR ANY OTHER ADDNL TREATMENT DIRECTIONS.
Ingred Name:SPILL PROC:STORAGE VESSEL FOR EPA APPROVED DISPOSAL.
Ingred Name:EYE PROT:& FULL LENGTH FACESHIELD .
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYE:CAUSES STINGING, BURNING,
WATERING OF EYES: INFLAM & REDNESS OF EYELIDS. EYES BECOME PAINFUL
& LIGHT SENSITIVE. CAN CAUSE CORNEAL DMG & BLINDNESS. SKIN:CAN
CAUSE BURNS, SYSTEMIC POISONING ASW/INGEST. ANESTH EFT. I.E. NO
PAIN W/WHITENING OF SKIN. ABSORPTION IS RAPID. MAY IN LIGHTER EXPOS
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:FORMALDEHYDE:IARC MONOGRAPHS, SUPP, VOL
TO (SUPDAT)
Effects of Overexposure:HLTH HAZ:CAUSES REDNESS, TINGLING-BURNING
SENSATION, SWELL, FATG, HDCH. INHAL:CAN CAUSE IRRIT & DMG TO MUC
MEMB, WATERING EYES, COUGH, SNEEZING, SALIVATION, NAUS, FATG,
VISUAL DISTURB, DIZZ & HDCH. IN GEST;SEV BURNS, SYSTEMIC POISONING,
MUSCULAR WEAK, TREMORS, CONVL, COLLAPSE, UNCON & DEATH. TOX DATA:
(SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
SHOULD BE HELD APART DURING IRRIGATION TO INSURE WATER CONT
W/ENTIRE SURF OF EYES & LIDS. CALL MD. SKIN:REMOVE CONTAMD CLTHG &
WASH CONTAMD SKIN W/LG AMTS OF WATER. CALL MD. INHAL:REMOVE
PATIENT FROM CONTAMD AREA. IF BRTHG HAS STOPPED, GIVE ARTF RESP,
PREFERABLY MOUTH-TO-MOUTH. CALL MD. INGEST:DILUTE BY DRINKING LARGE
QTYS OF (ING 6)
* Fire Fighting Measures *
Lower Limits:7%
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . USE WATER SPRAY TO COOL SURROUNDING CANS AND TO KNOCK
DOWN FUMES AND DILUTE MIXTURE.
Unusual Fire/Explosion Hazard:MAY PRODUCE TOXIC GASES UNDER FIRE
CONDITIONS.
* Accidental Release Measures *
Spill Release Procedures:NOT CONSIDERED FLAM; REMOVE FROM IGNIT
SOURCES. WEAR NIOSH APPRVD RESP & PROT CLTHG. VAPS MAY BE REDUCED
BY COVERING W/ALCOHOL-TYPE FOAM. SPILL CONTROL:SEAL OFF SPILL
AREAS. SM SPILLS:ABSORB MATLS CAN BE USED. LG SPILLS:DRAIN/PUMP TO
APPROP (ING 7)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:KEEP TIGHTLY CLOSED. STORE IN DRY,
AMMONIA PRODUCTS.
Other Precautions:PROTECT FROM HEAT, FLAME, AND IGNITION SOURCES.
* Physical/Chemical Properties *
Spec Gravity:1.1
pH:SUPDAT
Evaporation Rate & Reference:NOT KNOWN
Solubility in Water:COMPLETE
Appearance and Odor:LIGHT TAN TO AMBER LIQUID, WITH STRONG PUNGENT
ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
(AVOID CONT WITH):OXIDIZERS, CALCIUM HYPOCHLORITE, ALUMINUM CHLORIDE,
NITROBENZENE, BUTADINE, STRONG MINERAL (SUPDAT)
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:COMPLETE COMBUSTION - CARBON MONOXIDE,
CARBON DIOXIDE AND WATER VAPOR.
* Disposal Considerations *
Waste Disposal Methods:DISP MUST BE I/A/W FED, STATE & LOCAL REGS . SM
SPILLS MAY BE ABSORBED & DISPOSED OF BY BURNING IN EPA LICENSED
CHEM INCIN EQUIPPED W/AFTER-BURNER & SCRUBBER. LG SPILLS SHOULD BE
REMOVED BY LICE NSED WASTE HAULER & BURNED IN SIMILAR MANNER.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Ventilation:GENERAL DILUTION/LOCAL EXHAUST IN VOLUME & PATTERN TO KEEP
THE CONCENTRATION 1
Spec Gravity:0.7-1
Appearance and Odor:NON-VISCOUS LIQUID W/AN ODOR CHARACTERISTICS OF THE
SOLVENTS
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:ISOPROPANOL (ISOPROPYL ALCOHOL), 2-PROPANOL, DIMETHYL
CARBINOL
Ingred Name:ACETONE; DIMETHYL KETONE; 2-PROPANONE
Ingred Name:LIGHT ALIPHATIC NAPHTHA, VM & P NAPHTHA, LACOLENE
Ingred Name:PROPYLENEGLYCOL MONOMETHYL ETHER ACETATE,
1-METHOXY-2-PROPANOL ACETATE
Fraction by Wt: 2-5%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INGESTION: HARMFUL/FATAL. EYES: CAUSES
SEVERE IRRITATION. SKIN: IRRITATION, MAY BE ABSORBED. INHALATION:
HARMFUL, VAPOR MAY IRRITATE EYES, NOSE & THROAT. REPEATED EXPOSURE
MAY CAUSE IRRITATION TO RESP IRATORY SYSTEM & PERMANENT BRAIN &
NERVOUS SYSTEM DAMAGE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION. OVEREXPOSURE: EYE WATERING,
HEADACHES, NAUSEA, DIZZINESS, LOSS OF COORDINATION, REDNESS,
ITCHING, BURNING SENSATION, VISUAL DISTURBANCES, DRYNESS, CRACKING,
SWELLING.
* First Aid Measures *
First Aid:INGESTION: DON'T INDUCE VOMITING. EYES: FLUSH IMMEDIATELY
WATER FOLLOWED BY WASHING W/SOAP & WATER. INHALATION: REMOVE TO
FRESH AIR.GIVE CPR/OTHER SUPPORTIVE MEASURES AS REQUIRED. OBTAIN
MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Flash Point Method:PMCC
Lower Limits:1.5
Extinguishing Media:CO2, DRY CHEMICAL/UNIVERSAL AQUEOUS FILM FORMING
FOAM
Fire Fighting Procedures:WATER SPRAY MAY BE INEFFECTIVE. WATER SPRAY
MAY BE USED TO COOL CLOSED CONTAINERS TO PREVENT EXPLOSION. IF
WATER IS USED, FOG NOZZLES ARE PREFERRED. USE SCBA.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. TOXIC GASES MAY FORM WHEN PRODUCT IS
CONTACTED BY FLAME/HOT SURFACES.
* Accidental Release Measures *
Spill Release Procedures:PROVIDE MAXIMUM VENTILATION. ONLY PERSONNEL
PERMITTED IN THE AREA. REMOVE ALL IGNITION SOURCES. TAKE UP
MATERIAL W/SAWDUST, VERMICULITE/O THER ABSORBENT. PLACE INTO
CONTAINERS FOR DISPOSAL
*Handling and Storage *
QUANTITIES IN BUILDINGS DESIGNED & PROTECTED FOR STORAGE OF NFPA
CLASS IB FLAMMABLE LIQUIDS.
Other Precautions:READ MATERIAL SAFETY DATA SHEETS BEFORE BLENDING AS
THE RESULTING MIXTURE MAY HAVE THE HAZARDS OF ALL OF ITS PARTS.
CONTAINERS SHOULD BE GROUNDED WHEN POURING. AVOID FREE FALL OF
LIQUIDS IN EXCESS OF A FEW INCHES.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG ALKALIS, STRONG MINERAL ACIDS/STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAMES, ELECTRICAL
EQUIPMENT, HOT SURFACES & OTHER IGNITION SOURCES
Hazardous Decomposition Products:BY HEATING: CO
* Disposal Considerations *
Waste Disposal Methods:WASTE MATERIAL MUST BE DISPOSED OF IN ACCORDANCE
W/LOCAL, STATE & FEDERAL REGULATIONS. EMPTY CONTAINERS SHOULD BE
RECYCLED/DISPOSED OF THROUGH AN APPROVED WASTE MANAGEMENT FACILITY.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE NORMALLY REQUIRED.
Ventilation:MECHANICAL (GENERAL) VENTILATION IS RECOMMENDED.
Other Protective Equipment:NONE NORMALLY REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES.
LAUNDER CONTAMINATED CLOTHING BEFORE WEARING. KEEP WORK AREA CLEAN.
Supplemental Safety and Health
NOTE: THIS IS PART C OF A FIVE-PART KIT. THE STORAGE CODE AND SHIPPING
INFORMATION ARE FOR THE KIT AS A WHOLE. IF SEPERATED THIS COMPONENT
WOULD HAVE AN HCC CODE OF "N1".
* Product Identification *
Product ID:INHIBITOR COMPONENT(ALKALINE CONDITIONER)
Kit Part:Y
Preparer's Name:DR. D.O. ATKINS
* Composition/Information on Ingredients *
Ingred Name:SODIUM TETRABORATE, DECAHYDRATE
Other REC Limits:NONE SPECIFIED
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYE, SKIN & RESPIRATORY TRACT
IRRITATION. CHRONIC: NONE SPECIFIED BY MANUFACTURER.
Explanation of Carcinogenicity:THIS PRODUCT IS NOT LISTED BY IARC, NTP,
OR OSHA AS A CARCINOGEN.
Effects of Overexposure:EYE, SKIN & RESPIRATORY TRACT IRRITATION.
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF AILMENTS
OR WITH A PRE-EXISTING DISEASE INVOLVING THE EYES, SKIN, OR
RESPIRATORY TRACT MAY BE AT INCREASED RISK FROM EXPOSURE.
* First Aid Measures *
First Aid:INHALATION:REMOVE TO FRESH AIR. GIVE OXYGEN IF BREATHING IS
DIFFICULT .GET MEDICAL ATTENTION. EYES:IMMEDIATELY FLUSH WITH
ATTENTION. SK IN:REMOVE CONTAMINATED CLOTHING. WASH WITH SOAP AND
WATER. GET MEDICAL ADVICE IF IRRITATION PERSISTS. INGESTION:DO NOT
INDUCE VOMITING. GIVE NOTHING BY MOUTH IF UNCONSCIOUS. GET MEDICAL
ATTENTION.
* Fire Fighting Measures *
Flash Point:NONE
Autoignition Temp:Autoignition Temp Text:NONE
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE.
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
Spill Release Procedures:SWEEP UP AND DISCARD AS AN ALKALINE WASTE.
Neutralizing Agent:WATER DILUTION AND DILUTE ACID
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL, DRY AREA. KEEP
CONTAINERS TIGHTLY CLOSED WHEN NOT IN USE. PROTECT CONTAINERS FROM
PHYSICAL DAMAGE. KEEP AWAY FROM ACIDIC MATERIALS.
Other Precautions:DO NOT INGEST. DO NOT GET IN EYES. WASH THOROUGHLY
AFTER HANDLING AND BEFORE EATING, DRINKING OR SMOKING. AVOID
REPEATED OR PROLONGED CONTACT WITH SKIN.
* Physical/Chemical Properties *
HCC:N1
Vapor Pres:0
Solubility in Water:SLIGHT
Appearance and Odor:WHITE, FREE-FLOWING CRYSTALS; HYGROSCOPIC. NO ODOR
Percent Volatiles by Volume:0
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS
Stability Condition to Avoid:HIGH MOISTURE CONDITIONS
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE
* Disposal Considerations *
Waste Disposal Methods:DISSOLVE IN WATER. NEUTRALIZE TO PH 7 WITH
DILUTE ACID. FLUSH DOWN DRAIN IN ACCORDANCE WITH FEDERAL, STATE AND
LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IN CASE OF BRIEF EXPOSURE, USE NIOSH APPROVED
RESPIRATOR.
Ventilation:USE UNDER FUME HOOD.
FACESHIELD .
Other Protective Equipment:EYEWASH AND DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA . PROTECTIVE APRON.
Supplemental Safety and Health
MFR TRADE NAME/PART NO: OF COPPER IN 5% NITRIC ACID.
* Product Identification *
Resp. Party Other MSDS Num.:PLCU2
Preparer's Name:VANAJA SWAKUMAN
* Composition/Information on Ingredients *
Minumum % Wt:2.
Maxumum % Wt:5.
OSHA PEL:2 PPM
ACGIH TLV:2 PPM/4 STEL
Minumum % Wt:.1
Maxumum % Wt:1.
OSHA PEL:0.1MG/M3 FUME/1 DUST
ACGIH TLV:0.2 MG/M3 FUME
Ingred Name:WATER
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CORROSIVE. HARMFUL BY INGESTION.
IRRITATING TO THE EYES AND SKIN UPON CONTACT.
Effects of Overexposure:SEE HEALTH HAZARDS.
* First Aid Measures *
LIFTING UPPER AND LOWER EYELIDS. SKIN: REMOVE CONTAMINATED CLOTHING
AND FLUSH WITH WATER THOROUGHLY. INHALATION: MOVE TO FRESH AIR.
CONSULT DOCTOR IF SYMPTOMS PERSIST. INGESTION: GET IMMEDIATE
MEDICAL HELP. IF PATIENT IS CONSCIOUS, GIVE LARGE QUANTITIES OF
WATER.
* Fire Fighting Measures *
Flash Point:NOT APPLICABLE.
Extinguishing Media:APPROPRIATE TO SURROUNDING FIRE CONDITIONS.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:OXIDES OF NITROGEN CAN BE RELEASED IN
CASE OF FIRE.
* Accidental Release Measures *
Spill Release Procedures:VENTILATE AREA. WEAR PROTECTIVE EQUIPMENT. DO
NOT ALLOW TO ENTER DRAINAGE SYSTEMS OR WATER WAYS. DILUTE SPILL
WITH WATER AND NEUTRALIZE WITH SODA ASH, LIMESTONE, ETC. WIPE UP
AND PUT INTO SEALED CONTA INER FOR PROPER DISPOSAL. WASH SPILL SITE
OFF WITH WATER AFTER MATERIAL PICK UP IS COMPLETE. WEAR CHEMICAL
Neutralizing Agent:SODA ASH, LIMESTONE.
*Handling and Storage *
Handling and Storage Precautions:ENSURE GOOD VENTILATION/EXHAUSTION AT
WORK PLACE. HAVE AN IMMEDIATE AVAILABLITY OF AN EYE WASH IN CASE OF
EMERGENCY. STORE AT ROOM TEMPERATURE. KEEP THE CONTAINER TIGHTLY
CLOSED.
* Physical/Chemical Properties *
Spec Gravity:APPROXIMATELY 1.0
pH:1TO 2
Solubility in Water:MISCIBLE
Appearance and Odor:TRANSPARENT LIQUID WITH AN ACRID ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
REACTS WITH STRONG ALKALI, VARIOUS METALS, AND ORGANIC SUBSTANCES.
Stability Condition to Avoid:STABLE UNDER NORMAL STORAGE AND USE.
Hazardous Decomposition Products:TOXIC FUMES UNDER CONDITIONS OF FIRE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
* Toxicological Information*
Toxicological Information:MAY PRODUCE CAUSTIC EFFECT ON SKIN, MUCOUS
MEMBRANES AND EYES. SWALLOWING WILL LEAD TO A STRONG CAUSTIC EFFECT
ON MOUTH AND THROAT AND TO THE DANGER OF PERFORATION OF ESOPHAGUS
AND STOMACH. OVER EXPOS URE TO COPPER COMPOUNDS (PURE) MAY BE
RELATED TO LIVER DISEASE, HEART DISEASE, RHEUMATOID ARTHITIS AND
* Ecological Information *
Ecological:DO NOT ALLOW PRODUCT TO REACH GROUND WATER, WATER BODIES OR
SEWAGE SYSTEM.
* Disposal Considerations *
Waste Disposal Methods:CONTACT LOCAL HAZARDOUS OR CHEMICAL WASTE
DISPOSAL AGENCY FOR REGULTIONS. DISPOSAL MUST BE I/A/W FEDERAL,
STATE & LOCAL REGULATIONS .
* MSDS Transport Information *
PROPER SHIPPING NAME: CORROSIVE LIQUID, ACIDIC, INORGANIC, N.O.S.
GROUP: III, PROPE R SHIPPING NAME: CORROSIVE LIQUID, ACIDIC,
INORGANIC, N.O.S. (NITRIC ACID SOLUTION).
* Regulatory Information *
SARA Title III Information:USA: SARA: SUBJECT TO THE REPORTING
COMPONENTS OF THIS SOLUTION ARE REPORTED IN EPA TSCA INVENTORY
LIST.
Federal Regulatory Information:WHMIS CLASSIFICATION (CANADA): CLASS E.
CASE OF ACCIDENT OR IF YOU FEEL UNWELL, SEEK MEDICAL ADVICE
IMMEDIATELY.
* Other Information *
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Ventilation:LOCAL EXHAUST
Other Protective Equipment:APRON IS OPTIONAL
Supplemental Safety and Health
BUILDERS, CHELATING AGENTS & PHOSPHATES.
* Product Identification *
Product ID:TRI CHEM
CAGE:KGIND
CAGE:KGIND
* Composition/Information on Ingredients *
Ingred Name:POTASSIUM HYDROXIDE (SARA III)
OSHA PEL:C, 2 MG/M3
Ingred Name:SODIUM METASILICATE
Fraction by Wt: 4.0%
* Hazards Identification *
Effects of Overexposure:MAY CAUSE EYE & SKIN IRRITATION. HARMFUL IF
SWALLOWED.
* First Aid Measures *
INGESTION: CONSULT PHYSICIAN.
* Fire Fighting Measures *
Flash Point:NONE
* Accidental Release Measures *
Spill Release Procedures:MOP UP & RINSE WITH WATER.
*Handling and Storage *
Handling and Storage Precautions:STORE IN CLOSED CONTAINER AT AMBIENT
CONDITIONS.
* Physical/Chemical Properties *
Solubility in Water:SOLUBLE
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
* Disposal Considerations *
Waste Disposal Methods:FLUSH DILUTED PRODUCT INTO SANITARY SEWER
SYSTEM. DISPOSE OF CONCENTRATE IN ACCORDANCE WITH APPLICABLE
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF THE TLV IS EXCEEDED, USE A NIOSH APPROVED
ORGANIC VAPOR CARTRIDGE RESPIRATOR.
Ventilation:LOCAL EXHAUST: AS NEEDED TO CONTROL VAPOR/DUST LEVELS TO
BELOW RECOMMENDED LIMITS.
Other Protective Equipment:CLEAN PROTECTIVE CLOTHING. EYE WASH STATION.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
* Product Identification *
Preparer's Name:CATHY GRIFFITH
* Composition/Information on Ingredients *
Ingred Name:PETROLEUM OIL, HYDROTREATED HEAVY NAPHTHENIC DISTILLATE
(PETROLEUM), PETROLEUM DISTILLATES, MINERAL OIL (SEVERE)
Other REC Limits:1 MG(CU)/M3 (DUST)
OSHA PEL:0.1 MG(CU)/M3 (FUME)
ACGIH TLV:0.2 MG/M3 (FUME)
Ingred Name:CRYSTALLINE-QUARTZ SILICA, SILICA DUST (SUSPECTED HUMAN
Fraction by Wt: 1-3%
ACGIH TLV:0.1 MG/CUM RESP DUST
Ingred Name:GRAPHITE
Other REC Limits:2.5MG/CUM
ACGIH TLV:2 MG/CUM RESP IC
Ingred Name:VOLATILE ORGANIC CONTENT: 0.0 LBS/GAL
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN: MILD IRRITANT. INHALATION:
MAY CAUSE RESPIRATORY IRRITATION. ASPIRATION INTO THE LUNGS MAY
CAUSE CHEMICAL PNEUMONITIS. OVEREXPOSURE TO FREE RESPIRABLE QUARTZ
MAY CAUSE SILICOSIS/DELAYED LUN G INJURY. OVEREXPOSURE TO
COPPER/GRAPHITE DUST/FUMES MAY CAUSE LUNG INJURY.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, DEFATTING, REDNESS, NAUSEA,
VOMITING.
Medical Cond Aggravated by Exposure:PRE-EXISTING PULMONARY &
DERMATOLOGICAL DISORDERS.
* First Aid Measures *
THOROUGHLY W/SOAP & WATER. INHALATION: REMOVE TO FRESH AIR. GIVE
OXYGEN/CPR IF NEEDED. INGESTION: DON'T INDUCE VOMITING. GIVE
WATER/MILK IF CONSCI OUS & NOT DROWSY. IF VOMITING OCCURS, BE SURE
TO KEEP VICTIMS HEAD BELOW HIPS TO AVOID ASPIRATION OF VOMITUS INTO
THE LUNGS. OBTAIN MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Flash Point Method:PMCC
Extinguishing Media:FOAM, CO2, DRY CHEMICAL.
Fire Fighting Procedures:WEAR SCBA & PROTECTIVE CLOTHING. USE WATER TO
COOL EXPOSED CONTAINERS. WATER STREAM DIRECTED INTO FIRE MAY CAUSE
FROTHING W/SUBSEQUENT SPREAD OF FIRE.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY RUPTURE/EXPLODE DUE
TO PRESSURE BUILDUP WHEN EXPOSED TO EXTREME HEAT. IRRITATING/TOXIC
GASES/FUMES MAY GENERATE BY THERMAL COMBUSTION.
* Accidental Release Measures *
Spill Release Procedures:VENTILATE AREA. WEAR APPROPRIATE PROTECTIVE
EQUIPMENT DURING CLEANUP. CONTAIN & ABSORB W/INERT MATERIAL SUCH AS
VERMICULITE. PLACE INTO CONTAINERS W/LIDS. COVER LOOSELY & REMOVE
TO APPROPRIATE WASTE A REA. WASH AREA.
*Handling and Storage *
Handling and Storage Precautions:FOR PROFESSIONAL USE ONLY.
Other Precautions:DON'T TAKE INTERNALLY. AVOID CONTACT W/EYES,
SKIN/CLOTHING. AVOID BREATHING VAPOR/DUST/MIST. KEEP OUT OF REACH
OF CHILDREN.
* Physical/Chemical Properties *
Vapor Density:>1
Spec Gravity:1.3
pH:7
Evaporation Rate & Reference:SLOWER THAN N-BU AC
Solubility in Water:<0.1%
Appearance and Odor:VISCOUS LIQUID W/LITTLE ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:ACRID FUMES, OXIDES OF CARBON.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF EXPOSURE MAY OR DOES EXCEED OCCUPATION
EXPOSURE LIMITS USE A NIOSH-APPROVED RESPIRATOR TO PREVENT
ATMOSPHERE-SUPPLYING RESPIRATOR OR AN AI R-PURIFYING RESPIRATOR.
Ventilation:EXHAUST VENTILATION SUFFICIENT TO KEEP AIRBORNE
CONCENTRATIONS BELOW RESPECTIVE TLV'S.
Other Protective Equipment:CHEMICAL RESISTANT CLOTHING AS NECESSARY TO
PREVENT SKIN CONTACT. AN EMERGENCY EYEWASH AND SHOWER SHOULD BE
AVAILABLE.
Work Hygienic Practices:WASH HANDS THOROUGHLY WITH SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES.
Supplemental Safety and Health
REMOVE AND WASH CONTAMINATED CLOTHING BEFORE REUSE.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:STODDARD SOLVENT
Other REC Limits:NONE RECOMMENDED
Ingred Name:PETROLEUM LUBE OIL
Other REC Limits:NONE RECOMMENDED
Ingred Name:OXYGENATED HYDROCARBON
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 OIL MIST
ACGIH TLV:5 MG/M3 OIL MIST
Ingred Name:SODIUM PETROLEUM SULFONATE
Other REC Limits:NONE RECOMMENDED
Ingred Name:ETHYLENE GLYCOL MONOPROPYL ETHER,
Fraction by Wt: 0-7% %
Other REC Limits:NONE RECOMMENDED
Ingred Name:PROPASOL P
Fraction by Wt: 0-6% %
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EXPOSURE MAY CAUSE EYE IRRITATION,
SKIN IRRITATION. SWALLOWING SMALL AMOUNTS NOT HARMFUL. SWALLOWING
LARGE DOSES MAY BE HARMFUL. ASPIRATION HAZARD. BREATHING SMALL
AMOUNTS DURING NORMAL HANDLING IS NO T LIKELY TO CAUSE HARMFUL
EFFECTS.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:EYE IRRITATION, SKIN IRRITATION,
GASTROINTESTINAL IRRITATION, NAUSEA, VOMITING, DIARRHEA. BREATHING
AND LOSS OF CONSCIOUSNESS, DIZZINESS, STAGGERING GAIT, CONFUSION,
COMA. PROLONGED CONTACT WILL CAUSEDRYING AND CRACKING OF THE
SKIN. SKIN SENSITIZATION, ASTHMA OR OTHER ALLERGIC REACTION MAY
DEVELOP, CNS EFFECTS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
OPEN. GET MEDICAL ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING.
WASH WITH SOAP AND WATER. IF IRRITATION PERSIST, GET MEDICAL
ATTENTION. INH ALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. GET
MEDICAL ATTENTION. INGESTION: DO NOT INDUCE VOMITING. IF OCCURS,
KEEP HEAD BELOW HIPS. GET MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point Method:PMCC
Upper Limits:NOT GIVEN
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL
Fire Fighting Procedures:FIRE FIGHTERS SHOULD WEAR SELF CONTAINED
BREATHING APPARATUS AND FULL PROTECTIVE GEAR. COOL TANKS AND
CONTAINERS EXPOSED TO FIRE WITH WATER.
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR AND MAY
TRAVEL ALONG THE GROUND OR MOVED BY VENTILATION AND IGNITED BY
HEAT, PILOT LIGHTS, OTHER FLAMES OR IGNITION SOURCES.
* Accidental Release Measures *
Spill Release Procedures:ABSORB LIQUID ON VERMICULITE, FLOOR ABSORBENT
OR OTHER ABSORBENT MATERIALS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:CONTAINERS OF THIS MATERIAL MAY BE
HAZARDOUS WHEN EMPTIED. SINCE EMPTIED CONTAINERS RETAIN PRODUCT
RESIDUES ALL HAZARD PRECAUTIONS MUST BE OBSERVED.
Other Precautions:ALL FIVE GALLON PAILS AND LARGER METAL CONTAINERS
SHOULD BE GROUNDED AND/OR BONDED WHEN MATERIAL IS TRANSFERRED.
* Physical/Chemical Properties *
HCC:F4
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Vapor Pres:2
Vapor Density:NOT GIEN
Evaporation Rate & Reference:< 1 (ETHYL ETHER = 1)
Solubility in Water:NOT GIVEN
Appearance and Odor:AMBER LIQUID, ODOR UNSPECIFIED
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
VARIOUS HYDROCARBONS
* Disposal Considerations *
Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT, RESIDUE, DISPOSAL CONTAINER OR
LINER IN ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE REQD WHERE ADEQ VENT CNDTNS EXIST. IF
AIRBORNE CONC EXCEEDS TLV, A NIOSH/MSHA APPROVED DUST/MIST
RESPIRATOR IS RECOMMENDED. IF CONCENTRATION EXCEEDS CAPACITY OF
RESPIRATOR, A NIOSH/MSHA APPROVED SCBA IS ADVISED.
Ventilation:USE GENERAL OR LOCAL EXHAUST VENTILATION TO MEET TLV
REQUIREMENTS.
Other Protective Equipment:UNIFORM, APRON RECOMMENDED.
Work Hygienic Practices:WASH THORO AFTER HANDLING. AFTER CONTACT WITH
SKIN, WASH IMMEDIATELY WITH PLENTY OF WATER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:1,2-BENZISOTHIAZOLIN-3-ONE,1,1-DIOXIDE,SODIUM SALT;
Ingred Name:WATER
Fraction by Wt: 5-6%
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHAL: IRRIT OF UPPER RESPIRATORY
TRACT. SKIN: IRRITATION. EYE: IRRITATION. INGEST: MAY BE HARMFUL.
NOTE: REPORTED AS CAUSING CANCER IN LABORATORY ANIMALS. EXERCISE
DUE CARE.
Explanation of Carcinogenicity:SACCHARIN: IARC MONOGRAPHS, SUPP, VO 7,
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:
* First Aid Measures *
First Aid:INGEST: CALL MD. IF SWALLOWED, IF CONSCIOUS, IMMEDIATELY
INDUCE VOMITING. INHAL: REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE
ARTF RESP. IF BREATHING IS DIFFICULT, GIVE OXYGEN. SKIN: FLUSH SKIN
WITH WA TER. EYE: IMMEDIATELY FLUSH W/PLENTY OFWATER FOR AT LEAST
* Fire Fighting Measures *
Extinguishing Media:USE MEDIA SUITABLE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT.
Unusual Fire/Explosion Hazard:NONE IDENTIFIED.
* Accidental Release Measures *
Spill Release Procedures:WEAR NIOSH/MSHA SCBA & FULL PROTECTIVE
CLOTHING. WITH CLEAN SHOVEL, CAREFULLY PLACE MATERIAL INTO CLEAN,
DRY CONTAINER & COVER; REMOVE FROM AREA. FLUSH SPILL AREA WITH
WATER.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED. STORE
IN SECURE POISON AREA.
Other Precautions:NOTE: WHEN HANDLING LIQUID PRODUCTS, SECONDARY
PROTECTIVE CONTAINERS MUST BE USED FOR CARRYING. AVOID CONTACT WITH
EYES, SKIN, CLOTHING. AVOID BREATHING DUST.
* Physical/Chemical Properties *
Appearance and Odor:WHITE POWDER W/FAINT AROMATIC ODOR.
Percent Volatiles by Volume:0
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT, MOISTURE.
Hazardous Decomposition Products:OXIDES OF NITROGEN, OXIDES OF SULFUR,
CARBON MONOXIDE, CARBON DIOXIDE.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE IN ACCORDANCE W/ALL APPLICABLE FEDERAL,
STATE & LOCAL ENVIRONMENTAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:RESP PROT IS NOT NORMALLY NEEDED SINCE
VOLATILITY & TOXICITY ARE LOW. IF SIGNIFICANT VAPS, MISTS/AEROSOLS
ARE GENERATED, WEAR NIOSH/MSHA APPRVD/EQUIV RESP. FOR LG SPILLS,
ENTRY INTO LG TANKS, VESSELS/ ENCLSD SM SPACES W/INADEQ VENT, (ING
2)
Ventilation:GENERAL VENTILATION IS RECOMMENDED.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:IF CLOTHING IS CONTAMINATED, REMOVE CLOTHING &
THORO WASH AFFECTED AREA. LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
* Product Identification *
Product ID:ELIMINOX OXYGEN SCAVENGER
Preparer's Name:RICKY A. STACKHOUSE
* Composition/Information on Ingredients *
Ingred Name:NON HAZARDOUS INGREDIENTS
Ingred Name:RESP PROT:NIOSH/MSHA APPRVD PRESSURE-DEMAND, SCBA IS
RECOMMENDED.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE CONTACT:NON-IRRITATING. SKIN
CONTACT:CAN CAUSE TRANSIENT IRRITATION.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:A REVIEW OF AVAILABLE DATA DOES NOT IDENTIFY
ANY SYMPTOMS FROM EXPOSURE.
Medical Cond Aggravated by Exposure:A REVIEW OF AVAILABLE DATA DOES NOT
IDENTIFY ANY WORSENING OF EXISTING CONDITIONS.
* First Aid Measures *
MIN. INGEST:INDUCE VOMIT. GIVE WATER. CALL MD. INHAL:REMOVE TO
FRESH AIR. SUPPORT BRTHG (GIVE O*2/ARTF RESP) . CAUTION:IF UNCON,
HAV ING TROUBLE BRTHG/IN CONVLS, DO NOT INDUCE VOMIT/GIVE WATER.
NOTE TO MD:NO SPEC ANTIDOTE IS KNOWN. BASED ON INDIVIDUAL RXNS OF
PATIENT, MD'S JUDGMENT SHOULD BE USED TO CONTROL SYMPS & CLINICAL
CNDTN.
* Fire Fighting Measures *
Flash Point Method:PMCC
Flash Point:NONE
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:MAY EVOLVE NO*X UNDER FIRE CNDTNS. CNTNRS
EXPOSED IN FIRE SHOULD BE COOLED W/WATER TO PREVENT VAPOR PRESSURE
BUILDUP LEADING TO RUPTURE.
* Accidental Release Measures *
Spill Release Procedures:SM SPILL:CONTAIN W/ABSORB MATL, SUCH AS CLAY,
SOIL/ANY COMMERCIALLY AVAIL ABSORB. SHOVEL RECLAIMED LIQ & ABSORB
LG LIQ SPILLS:DIKE TO PVNT FURTHER MOVEMENT & RECLAIM INTO (SUPP
DATA)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:MAY CAUSE SKIN IRRITATION. AVOID
CONTACT W/SKIN & CLOTHING. AVOID PROLONGED OR REPEATED BREATHING OF
VAPOR. USE W/ADEQUATE VENTILATION.
Other Precautions:DO NOT TAKE INTERNALLY. EMPTY CONTAINERS MAY CONTAIN
RESIDUAL PRODUCT. DO NOT REUSE CONTAINER UNLESS PROPERLY
RECONDITIONED.
MATLS TO AVOID:PERCHLORATES, CONC O*2, PERMANGANATES)WHICH CAN GENERATE
HEAT, FIRES, EXPLOS & RELEASE OF TOX FUMES. SPILL
PROC:RECOVERY/SALVAGE DRUMS/TANK TRUCK FOR DISP. REFER TO CERCLA IN
ALSO BE DEEP-WELL INJECTED I/A/W LOC, STATE & FED REGS.
* Physical/Chemical Properties *
HCC:N1
pH:7.3
Solubility in Water:COMPLETELY
Appearance and Odor:COLORLESS LIQUID.
* Stability and Reactivity Data *
AVOID MINERAL ACIDS & NITRITES. AVOID CNTCT W/STRONG OXIDIZERS (EG.
CHLORINE, PEROXIDES, CHROMATES, NITRIC ACID,(SUPDAT)
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:IN EVENT OF COMBUSTION CO, CO*2, NO*X
MAY BE FORMED. DO NOT BREATHE SMOKE OR FUMES.
* Disposal Considerations *
Waste Disposal Methods:IF PROD BECOMES WASTE, IT DOES NOT MEET CRITERIA
IT SHOULD BE SOLIDIFIED W/STABILIZING AGENTS (SUCH AS SAND/FLY
ASH/CEMENT) SO THAT N O FREE LIQ REMAINS BEFORE DISP TO
INDUS(SUPDAT)
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NO SPECIFIC RESPIRATORY PROTECTION IS REQUIRED
FOR THIS PRODUCT OTHER THAN WHAT WOULD BE NEEDED FOR THE WORK TASK
WORK AREA IN WHICH THIS PRODUCT IS BEING USED. USE NIOSH/MSHA
APPROVED RESPIRATOR APPR OPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:NONE REQUIRED AT CONCENTRATIONS BELOW TLV OR PEL, WHICH
EVER IS LESS.
Other Protective Equipment:EMERGENCY EYEWASH & DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRST AID PROC:TO SUPPORT VITAL FUNCTIONS. CALL LOC POIS CTL CTR/EMER
MD FOR ADDNL INFO. SKIN:FLUSH W/COPIOUS AMTS OF WATER. SEE MD .
INGEST:CALL MD IMMED . VICTIM OF CHEM EXPOS & ALL RESC UERS MUST BE
TAKEN FOR MD ATTN. TAKE COPY OF LABEL & MSDS TO MD/HLTH
PROFESSIONAL W/VICTIM. NOTE TO MD:TREAT EXPOS SYMP.
* Product Identification *
Product ID:CUT-TO-FIT ROLLS AND PADS, FIBERGLASS
* Composition/Information on Ingredients *
Ingred Name:FIBERGLASS; FILTRATION MEDIA, FIBERGLASS FILTERS, FIBROUS
GLASS)
OSHA PEL:5 MG/M3 RESP DUST
Ingred Name:UREA EXTENDED PHENOL-FORMALDEHYDE RESIN CURED
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:POLYESTER; (FISTRATION MEDIA, POLYESTER FILTERS, POLYESTER)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PARAFFIN; (ADHESIVE PARAFFIN WAX)
Fraction by Wt: <1%
OSHA PEL:2 MG/M3 (FUME)
ACGIH TLV:2 MG/M3 (FUME)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: NO ADVERSE ACUTE HEALTH EFFECTS
HAVE BEEN OBSERVED UNDER NORMAL USAGE. INHALATION: FIBER GLASS DUST
AND/OR COTTON-POLYESTER FIBERS MAY CAUSE IRRITATION IN THROAT OR
NOSE. SKIN/EYES: CONTACT OF FIBER GLASS DUST AND/OR
COTTON-POLYESTER FIBERS MAY CAUSE TEMPORARY IRRITATION OR RASH.
INGESTION: (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: FIBER GLASS AND/OR COTTON-POLYESTER
FIBERS MAY CAUSE TEMPORARY IRRITATION TO GASTROINTESTINAL TRACT.
CHRONIC: EXPOSURE TO FIBROUS GLASS HAS BEEN SHOWN TO CAUSE CANCER
OF THE RESPIRATORY TRAC T.
Medical Cond Aggravated by Exposure:ANY PREEXISTING UPPER RESPIRATORY
OR LUNG DISEASE MAY BE AGGRAVATED BY INHALATION OF FIBROUS GLASS
DUST.
* First Aid Measures *
First Aid:UNDER NORM USAGE, NO APPARENT CNDTNS EXIST THAT WOULD REQUIRE
FIRST AID AFTER EXPOS TO THIS ARTICLE. EYES: OPEN EYES WHILE UNDER
GENTLE RUNNING WATER. USE SUFFICIENT FORCE TO OPEN EYELIDS. HAVE
IS INVOLVED IN A FIRE, & PERS ARE EXPOSED TO SMOKE/FUMES GENERATED
FROM MATL, REMOVE VICTIM TO FRESH AIR & USE ARTF RESP IF NEC (SUP
DAT)
* Fire Fighting Measures *
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, FOAM, DRY CHEMICAL,
HALON.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . IF THIS ARTICLE IS INVOLVED IN FIRE, USE
WATER FOG, WATER SPRAY/DRY CHEMICAL.
Unusual Fire/Explosion Hazard:RESIN AND/OR POLYESTER CAN BURN,
GENERATING ACRID SMOKE.
* Accidental Release Measures *
Spill Release Procedures:UNDER NORMAL USAGE, NO APPARENT CONDITIONS
EXIST THAT REQUIRE EMERGENCY SPILL RESPONSE. WORKERS INVOLVED IN
ROUTINE CLEAN UP OR MAINTENANCE SHOULD USE PROTECTIVE CLOTHING AS
NECESSARY FOR THE WORK TAS K BEING PERFORMED.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
* Physical/Chemical Properties *
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
HYDROFLUORIC ACID, STRONG OXIDIZERS.
Stability Condition to Avoid:EXTREMELY HIGH TEMPERATURES WILL CAUSE
THIS MATERIAL TO MELT AND POSSIBLY BURN, GENERATING ACRID SMOKE AND
FUMES.
Hazardous Decomposition Products:ACRID SMOKE AND FUMES.
* Disposal Considerations *
Waste Disposal Methods:WASTE DISPOSAL MUST BE IN ACCORDANCE WITH
APPROPRIATE FEDERAL, STATE, AND LOCAL REGULATIONS. THIS PRODUCT IF
UNALTERED BY HANDLING, MAY BE DISPOSED OF AS NON-HAZARDOUS WASTE.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WHERE AIR CONTAMS CAN EXCEED ACCEPT CRITERIA,
USE NIOSH/MSHA APPRVD RESP PROT EQUIP. RESPIRATORS SHOULD BE
Ventilation:LOCAL EXHST REC. IF AIRBORNE CONTAMS ARE GENERATED WHEN
MATL IS HEATED/HNDLD, SUFFICIENT VENT IN VOL & AIR FLOW (SUPDAT)
Other Protective Equipment:NO INFORMATION GIVEN BY MFR.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EXPLO HAZ:PUNCTURE CNTNR. CONTENTS UNDER PRESS WILL DISCHARGE. AVOID
OPEN FLAMES, SPKS, PILOT LIGHTS. DO NOT SMOKE. FIRST AID PROC:GIVE
ARTF RESP, PREF MOUTH-TO-MOUTH. VENT:PATTERNS SHOULD BE PROVIDED
TO KEEP AIR CONTAM CONC LEVELS BELOW ACCEPTABLE CRITERIA.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:PROPANE
ACGIH TLV:ASPHYXIANT
Ingred Name:TOLUENE (SARA III)
Ingred Name:HEXANE; (N-HEXANE)
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:LACOLENE; (LIGHT ALIPHATIC SOLVENT NAPHTHA (PETROLEUM))
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN:CAUSES IRRITATION.
INGEST:NOT EXPECTED TO BE HARMFUL UNDER NORMAL CONDITIONS OF USE.
IF ACCIDENTALLY SWALLOWED, BURNS OR IRRITATION TO MUCOUS MEMBRANES,
ESOPHAGUS OR GI TRACT CAN RESULT. INH AL:MAY BE HARMFUL. LIQUID OR
VAPOR MAY CAUSE IRRITATION OF NOSE, THROAT & LUNGS. CAN CAUSE
CENTRAL (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:NERVOUS SYSTEM DEPRESSION.
NOTE:TOLUENE APPEARS ON THE NAVY LIST OF OCCUPATIONAL CHEMICAL
REPRODUCTIVE HAZARDS. SEEK CONSULTATION FROM APPROPRIATE HEALTH
PROFESSIONALS CONCERNING LATEST HAZAR D LIST INFO & SAFE HANDLING &
EXPOSURE INFO .
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
APART DURING IRRIGATION TO INSURE WATER CONT W/ENTIRE SURF OF EYES
& LIDS. CALL MD. SKIN:FLUSH W/PLENTY OF WATER. REMOVE CONTAM CLTHG.
CALL MD IF IRRIT PERSISTS. INGEST:DILUTE BYDRINKING LG QTYS OF
WATER. IMMED CONT POIS CTL CTR/HOSPITAL EMER ROOM FOR ANY OTHER
ADDNL TREATMENT DIRECTIONS. INHAL:REMOVE TO FRESH AIR. IF NOT
BRTHG,(SUPDAT)
* Fire Fighting Measures *
Extinguishing Media:DRY CHEMICAL, FOAM OR CO*2. WATER MAY BE
INEFFECTIVE, BUT SHOULD BE USED TO KEEP FIRE-EXPOSED CONTAINERS
COOL.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
MAY CAUSE BURSTING. DO NOT PLACE CNTNR ON RADIATOR, STOVE, IN
DIRECT SUNLIGHT/NEAR OTHER HEAT SOURCES. DO NOT (SUPDAT)
* Accidental Release Measures *
Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES. SOAK UP
W/ABSORBENT MATERIAL & REMOVE TO A CHEMICAL DISPOSAL AREA. PREVENT
ENTRY INTO NATURAL BODIES OF WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
KEEP AWAY FROM HEAT, SPARKS, FLAME & OTHER IGNITION SOURCES.
Other Precautions:NO INFORMATION GIVEN BY MANUFACTURER.
* Physical/Chemical Properties *
HCC:V3
Vapor Density:HVR/AIR
Spec Gravity:LTR/WATER
Solubility in Water:SLIGHT
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZERS, ACIDS OR BASES.
Stability Condition to Avoid:NO INFORMATION GIVEN BY MFR.
Hazardous Decomposition Products:OXIDES OF CARBON.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF ACCORDING TO LOCAL, STATE/PROVINCIAL
& FEDERAL REQUIREMENTS. EMPTY CONTAINER MAY CONTAIN EXPLOSIVE
VAPORS. DO NOT CUT, PUNCTURE OR WELD ON OR NEARBY. INCINERATION
WILL CAUSE CONTAINER TO BU RST VIOLENTLY.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Ventilation:MECHANICAL EXHAUST
Work Hygienic Practices:WASH SKIN & HANDS AFTER USE.
Supplemental Safety and Health
SPIRITS). LOWER EXPLOSIVE LIMIT: 1 (MINERAL SPIRITS). UPPER
EXPLOSIVE LIMIT: 6 (MINERAL SPIRITS).
* Product Identification *
* Composition/Information on Ingredients *
Fraction by Wt: 2%
Ingred Name:ETHYLENE GLYCOL, GLYCOL
Fraction by Wt: 2%
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SYMPTOMS OF EXPOSURE INCLUDE:
DIZZINESS, ABDOMINAL DISCOMFORT, CNS DEPRESSION, HEADACHE,
CONJUNCTIVITIS, NAUSEA, MUCOUS MEMBRANE IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SYMPTOMS OF EXPOSURE INCLUDE: DIZZINESS,
ABDOMINAL DISCOMFORT, CNS DEPRESSION, HEADACHE, CONJUNCTIVITIS,
NAUSEA, MUCOUS MEMBRANE IRRITATION
* First Aid Measures *
VOMITING, GIVE WATER. OBTAIN MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Flash Point Method:TOC
Lower Limits:(SEE SUPP)
Upper Limits:(SEE SUPP)
Extinguishing Media:CO2, FOAM, DRY CHEMICAL, WATER
Fire Fighting Procedures:USE A SELF CONTAINED BREATHING APPARATUS IN
POSITIVE PRESSURE MODE & FULL PROTECTIVE GEAR.
Unusual Fire/Explosion Hazard:IRRITATING/TOXIC GASES & AEROSOLS MAY BE
PRODUCED DURING BURNING
* Accidental Release Measures *
Spill Release Procedures:SCRAPE INTO CONTAINERS & DISPOSE OF.
*Handling and Storage *
Handling and Storage Precautions:DON'T STORE NEAR HEAT SOURCES,
Other Precautions:DON'T INGEST. KEEP AWAY FROM CHILDREN. NOT FOR
UNDERWATER USE.
* Physical/Chemical Properties *
Boiling Pt:B.P. Text:(SEE SUPP)
Vapor Pres:(SEE SUPP)
Vapor Density:>1
Spec Gravity:1.6
Evaporation Rate & Reference:SLOWER THAN BU ACETATE
Solubility in Water:COMPLETE
Appearance and Odor:WHITE/PIGMENTED SEMI-SOLID W/SLIGHT ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:FREEZING
Hazardous Decomposition Products:CO, CO2
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL AND GENERAL VENTILATION NECESSARY TO KEEP AIR
CONCENTRATION BELOW TLV .
Other Protective Equipment:NONE
Work Hygienic Practices:N/K
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:METHYLENE CHLORIDE(SARA III)
Other REC Limits:N/K
Ingred Name:METHYL ALCOHOL (METHANOL) (SARA III)
Fraction by Wt: 6.0%
Other REC Limits:N/K
Ingred Name:PROPANE
Other REC Limits:N/K
Ingred Name:INERT INGREDIENTS
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:THICKENERS
Fraction by Wt: 3.0%
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:SEE SIGNS AND SYMPTOMS OF
OVEREXPOSURE.
Explanation of Carcinogenicity:METHYLENE CHLORIDE:INAD EVID FOR CARCIN
Effects of Overexposure:EYES:N/K .SKIN:VERY IRRITATING.CAUSES BURNING
AND REDNESS.INGESTION:N/K .INHALATION:MAY CAUSE DIZZINESS.IN
EXTREME CASES,ABSENCE OF OXYGEN COULD PRODUCE NARCOSIS.
Medical Cond Aggravated by Exposure:N/K
* First Aid Measures *
First Aid:EYES:IF SPRAYED IN EYES,FLUSH IMMEDIATELY WITH LARGE
WATER.IF REDNESS PERSISTS SEE A PHYSICIAN.INGESTION:CALL MD
IMMEDIATELY .IN HALATION:IF UNCONSCIOUS,REMOVE PERSON TO FRESH AIR
AND CALL A PHYSICIAN.
* Fire Fighting Measures *
Flash Point Method:TCC
Upper Limits:1.8
Extinguishing Media:WATER FOG,FOAM,CARBON DIOXIDE,DRY CHEMICAL.
Fire Fighting Procedures:WEAR PRESSURE DEMAND SCBA AND FULL PROT EQUIP
.KEEP CONTAINERS COOL.USE EQUIP/SHIELDING REQD TO PROTECT PERSONNEL
AGAINST BURSTING/VENTING CONTAINERS.
OVER) CONTAINERS MAY VENT,RUPTURE OR BURST.HAZ DECOMP PROD:THERMAL
DECOMPOSITION PRODUCTS MAY INCLUDE HCL & (SEE SUP DATA)
* Accidental Release Measures *
Spill Release Procedures:FLUSH WITH LARGE QUANTITIES OF WATER.VENTILATE
AREA.
Neutralizing Agent:N/K
*Handling and Storage *
Handling and Storage Precautions:AVOID BRTHG CONCENTRATED VAP/PARTICLES
FROM ALL PROD NOT SPECIFICALLY DESIGNED FOR INHAL.READ/FOLLOW
Other Precautions:NO SMOKING IN AREA OF USE.DO NOT USE IN THE GENERAL
VICINITY OF ARC WELDING,OPEN FLAMES OR HOT SURFACES.HEAT AND/OR UV
RADIATION MAY CAUSE THE FORMATION OF HCL AND/OR PHOSGENE .
* Physical/Chemical Properties *
Melt/Freeze Pt:M.P/F.P Text:N/K
Decomp Temp:Decomp Text:N/K
Vapor Pres:SEE SUPP
Vapor Density:4.0,AIR=1
pH:NONE
Solubility in Water:>1%
Appearance and Odor:CLEAR GEL (LIQUID,SOLID,GAS) WITH SOLVENT ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:PRESSURIZED CONTAINERS COULD RUPTURE ABOVE
Hazardous Decomposition Products:HCL,PHOSGENE .ALSO CARBON
DIOXIDE,CARBON MONOXIDE AND WATER (FROM BURNING).
* Disposal Considerations *
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH
FEDERAL,STATE AND LOCAL REGULATIONS .DO NOT PUNCTURE OR INCINERATE
CONTAINERS.GIVE TO DISPOSAL SERVICE EQUIPPED TO SAFELY HANDLE AND
DISPOSE OF PRESSURIZED CO NTAINERS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR IF REQUIRED.
Ventilation:NORMAL, TO KEEP BELOW TLV.
Other Protective Equipment:LAUNDER SOILED WORK CLOTHING AT LEAST
WEEKLY.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:MINERAL OIL (EXPOSURE REGULATED AS 'OIL MIST')
OSHA PEL:5 MG/M3
Ingred Name:ZINC DITHIOPHOSPHATE
Fraction by Wt: 1-5%
Ingred Name:METHACRYLATE COPOLYMER
Fraction by Wt: <1%
* Hazards Identification *
Effects of Overexposure:EYE:MINOR IRRIT. SKIN:POSS REDNESS,EDEMA, OR
DRYING. MAY CAUSE DERMATITIS ON RPTD/PRLNG CONTACT.
* First Aid Measures *
SOAP AND WATER, SEVERAL TIMES DAILY.
* Fire Fighting Measures *
Extinguishing Media:WATER SPRAY, DRY CHEMICAL, ALCOHOL FOAM, CO*2
Fire Fighting Procedures:USE H*2O TO COOL FIRE-EXPOSED CANS,SCBA
Unusual Fire/Explosion Hazard:WATER OR FOAM MAY CAUSE FROTHING. CO,
CO*2, ALDEHYDES, KETONES AND COMBUSTION PROD OF N AND S FORM.
* Accidental Release Measures *
Spill Release Procedures:CONTAIN SPILL. ABSORB W/ INERT POROUS
MATERIAL. IF A LEAK OR SPILL HAS NOT IGNITED, USE WATER SPRAY TO
DISPERSE VAPORS AND TO PROVIDE PROTECTION FOR PERSONS ATTEMPTING TO
STOP THE LEAK.
*Handling and Storage *
Handling and Storage Precautions:PERIODS OF EXPOSURE TO HIGH TEMPS
SHOULD BE MINIMIZED.
Other Precautions:THIS PRODUCT IS BELIEVED TO BE MINIMALLY IRRITATING
IF NOT IN EXCESS OF PERMISSIBLE CONCENTRATIONS. EXERCISE REASONABLE
PERSONAL CLEANLINESS.
* Physical/Chemical Properties *
HCC:V6
Boiling Pt:B.P. Text:N/D
Evaporation Rate & Reference:N/L
Solubility in Water:INSOLUBLE
Appearance and Odor:PALE COLOR
Percent Volatiles by Volume:0
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:CO,CO*2,ALDEHYDES,KETONES,COMBUSTION
PROD OF N AND S.
* Disposal Considerations *
Waste Disposal Methods:MFR RECOMMENDS: DISPOSE AS AN OILY WASTE.
CONTACT A WASTE OIL CONTRACTOR OR DISPOSAL SPECIALIST IF NECESSARY.
DISPOSAL METHOD MUST BE IAW FEDERAL, STATE AND LOCAL CODES.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:MECHANICAL EXHAUST REQUIRED.
Other Protective Equipment:WEAR SUITABLE PROTECTIVE CLOTHING. SAFETY
SHOWER AND EYE BATH.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:TETRAKIS (DECYL) AMMONIUM BROMIDE
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY BE HARMFUL BY INHALATION,
INGESTION, OR SKIN ABSORPTION. CAUSES EYE AND SKIN IRRITATION.
MATERIAL IS IRRITATING TO MUCOUS MEMBRANES AND UPPER RESPIRATORY
TRACT. TO THE BEST OF OUR KNOWLEDGE, THE C HEMICAL, PHYSICAL, AND
TOXICOLOGICAL PROPERTIES HAVE NOT BEEN THOROUGHLY INVESTIGATED.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:
* First Aid Measures *
First Aid:EYES: IMMEDIATELY FLUSH WITH COPIOUS AMOUNTS OF WATER FOR AT
AMOUNTS OF WATER. WASH CONTAMINATED CLOTHING BEFORE REUSE.
INHALATION: REMO VE TO FRESH AIR. IF NOT BREATHING GIVE ARTIFICIAL
RESPIRATION. IF BREATHING IS DIFFICULT, GIVE OXYGEN. INGESTION:
WASH OUT MOUTH WITH WATER PROVIDED PERSON IS CONSCIOUS. CALL
PHYSICIAN.
* Fire Fighting Measures *
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL POWDER OR
APPROPRIATE FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:EMITS TOXIC FUMES UNDER FIRE CONDITIONS.
* Accidental Release Measures *
Spill Release Procedures:WEAR NIOSH/MSHA APPROVED RESPIRATOR, CHEMICAL
PLACE IN A BAG AND HOLD FOR WASTE DISPOSAL. AVOID RAISING DUST.
VENTILATE AREA AND WASH SP ILL SITE AFTER MATERIAL PICKUP IS
COMPLETE.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:KEEP TIGHTLY CLOSED. HYGROSCOPIC.
STORE IN A COOL DRY PLACE.
Other Precautions:IRRITANT. DO NOT BREATHE DUST. AVOID CONTACT WITH
EYES, SKIN AND CLOTHING. IRRITATING TO EYES, RESPIRATORY SYSTEM AND
SKIN.
* Physical/Chemical Properties *
Appearance and Odor:WHITE CRYSTALLINE POWDER.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:MOISTURE.
Hazardous Decomposition Products:TOXIC FUMES OF: CARBON MONOXIDE,
CARBON DIOXIDE, NITROGEN OXIDES, HYDROGEN BROMIDE GAS.
* Disposal Considerations *
Waste Disposal Methods:DISSOLVE OR MIX MATERIAL WITH A COMBUSTIBLE
SOLVENT AND BURN IN A CHEMICAL INCINERATOR EQUIPPED WITH AN
AFTERBURNER AND SCRUBBER. DISPOSE OF IN ACCORDANCE WITH FEDERAL,
STATE AND LOCAL REGULATIONS (FP N).
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL AND GENERAL VENTILATION NECESSARY TO KEEP AIR
CONCENTRATION BELOW TLV .
Other Protective Equipment:NONE
Work Hygienic Practices:N/K
Supplemental Safety and Health
PROC:VENTING,RUPTURING OR BURSTING CONTR.OTHER
PREC:DIRECTIONS/PRECAUTIONS BEFORE USE.FOR INDUSTRIAL USE
ONLY.HARMFUL/FATAL IF SW ALLOWED/DELIBERATELY INHALED.NON-TOXIC
AFTER APPLIED AND DRY.KEEP OUT OF THE REACH OF CHILDREN.
* Product Identification *
Product ID:KOT CLEAR COAT PAINT
* Composition/Information on Ingredients *
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)
Fraction by Wt: <5%
Other REC Limits:N/K
Ingred Name:PROPANE
Other REC Limits:N/K
Ingred Name:ISOBUTANE
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:4-METHOXY-4-METHYL-2-PENTANONE
Fraction by Wt: <5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:METHYLENE CHLORIDE(SARA III)
Ingred Name:TOLUENE (SARA III)
Other REC Limits:N/K
* Hazards Identification *
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:MAY BE HARMFUL OR FATAL IF SWALLOWED
OR DELIBERATELY INHALED.CAN CAUSE LIVER DISEASE.CHRONIC EFFECTS:CAN
CAUSE MENTAL CONFUSION,DEPRESSION,FATIGUE,LOSS OF
APPETITE,NAUSEA,VOMITING,COUGH,LOSS OF SENSE OF BALANCE AND VISUAL
DISTURBANCES.
Explanation of Carcinogenicity:METHYLENE CHLORIDE:INADEQ EVID FOR
CARCIN IN HUM/SUFF EVID FOR CARCIN IN ANIM (IARC
Effects of Overexposure:EYES/SKIN:DIRECT CONTACT MAY CAUSE
IRRITATION.INGEST:MAY BE HARMFUL OR FATAL IF
SWALLOWED.INHAL:HEADACHE,NAUSEA,DROWSINESS,DIZZINESS,NASAL AND
RESPIRATORY IRRITATION.
Medical Cond Aggravated by Exposure:N/K
* First Aid Measures *
MIN.GET MD.SKIN:WASH W/ PLENTY OF SOAP & H*2O.IF IRRIT PERSISTS,GET
MD.INGEST:MAY BE HARMFUL/FATAL.DO NOT INDUCE VOMIT.CALL MD
IMMED.INHAL:MOVE TO FRESH AIR.IF IRRIT PERSISTS,GET MD.NOTE TO
PHYSICIAN:METHYLENE CHLORIDE MAY CAUSE ELEVATED CARBOXYHEMOGLOBIN
LEVELS & INCREASED MYOCARDIAL IRRITABILITY.AVOID EPINEPHRINE &
DRUGS W/ SIMILAR ACTION.
* Fire Fighting Measures *
Flash Point:SEE SUPP DATA
Lower Limits:N/K
Upper Limits:N/K
Extinguishing Media:CARBON DIOXIDE,DRY CHEMICAL OR FOAM.
Fire Fighting Procedures:WEAR PRESSURE DEMAND SCBA AND FULL PROTECTIVE
EQUIPMENT .H*2O MAY BE INEFFECTIVE.KEEP CANS COOL.PROVIDE SHIELDING
TO PROTECT PERSONNEL FROM (SEE SUPP)
Unusual Fire/Explosion Hazard:EXTREMELY FLAMM.EXPOSURE TO TEMP
CAUSE FORMATION OF CO*2,CO,HYDROGEN CHLORIDE OR PHOSGENE GAS.
* Accidental Release Measures *
Spill Release Procedures:REMOVE SOURCES OF HEAT,SPARKS OR
FLAME.VENTILATE AREA OF SPILL.ABSORB SPILL ON OIL ABSORBENT,SAND OR
VERMICULITE.
Neutralizing Agent:N/K
*Handling and Storage *
Handling and Storage Precautions:EXTREMELY FLAMMABLE.CONTENTS UNDER
PRESS.DO NOT USE OR STORE NEAR SPARKS OR FLAME.DO NOT STORE IN
Other Precautions:NO SMOKING IN AREA OF USE.DO NOT USE IN THE GENERAL
VICINITY OF ARC WELDING,OPEN FLAMES OR HOT SURFACES.HEAT AND/OR UV
RADIATION MAY CAUSE THE FORMATION OF HCL &/OR PHOSGENE .DO NOT
PUNCTURE OR INCIN.READ & FOLLOW LABEL (SEE SUPP)
* Physical/Chemical Properties *
Melt/Freeze Pt:M.P/F.P Text:N/K
Decomp Temp:Decomp Text:N/K
Vapor Pres:N/K
Vapor Density:N/K
Evaporation Rate & Reference:N/K
Solubility in Water:NEGLIGIBLE
Appearance and Odor:AEROSOL CLEAR ACRYLIC SPRAY PAINT WITH A PETROLEUM
ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS,ALKALI METALS OR CAUSTICS.MAY AFFECT SOME PLASTICS.
Stability Condition to Avoid:EXPOSURE TO TEMPERATURE
Hazardous Decomposition Products:BURNING MAY RESULT IN FORMATION OF
CARBON DIOXIDE,CARBON MONOXIDE,HYDROGEN CHLORIDE OR PHOSGENE GASES.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
* Disposal Considerations *
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH
FEDERAL,STATE AND LOCAL REGULATIONS .DO NOT PUNCTURE OR INCINERATE
CANS.GIVE EMPTY CANS TO A DISPOSAL SERVICE EQUIPPED TO SAFELY
DISPOSE OF PRESSURIZED CONTAI NERS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL AND GENERAL VENTILATION NECESSARY TO KEEP AIR
CONCENTRATION BELOW TLV .
Other Protective Equipment:SOLVENT IMPERMEABLE CLOTHING,AND BOOTS ARE
RECOMMENDED TO PREVENT SKIN CONTACT.
Work Hygienic Practices:N/K
Supplemental Safety and Health
EXPLO HAZ:NON-EXPLO PROOF EQUIP,DURING USE AND UNTIL ALL VAPS ARE
GONE.VAPS MAY IGNITE EXPLOSIVELY.VAPS MAY SPREAD LONG DISTANCES AND
BEYOND CLOSED DOORS.PREVENT BUILD UP OF VAPS BY MAINTAINING A CONT
FLOW OF FRESH AIR.HAZ DECOMP PRODS MAYINCL TOX FUMES.HLTH HAZ:MAY
BE HARMFUL OR FATAL.SPILL PROC:ABSORB ON (SEE ING 7)
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:2,4,6-TRI(DIMETHYLAMINOMETHYL)PHENOL.VP:0 MMHG.
Fraction by Wt: 1%
Other REC Limits:5 PPM MFR
OSHA PEL:5 PPM SKIN
ACGIH TLV:5 PPM SKIN
Ingred Name:2-BUTOXYETHANOL
Fraction by Wt: 5%
Other REC Limits:N/K
Ingred Name:TOLUENE (SARA III)
Fraction by Wt: 3%
Other REC Limits:N/K
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)
Fraction by Wt: 4%
Other REC Limits:N/K
Ingred Name:ISOPROPYL ALCOHOL (SARA III)
Fraction by Wt: 3%
Other REC Limits:N/K
Ingred Name:ETHYL ALCOHOL (ETHANOL)
Fraction by Wt: 1%
Other REC Limits:N/K
Ingred Name:INERT MATLS & SHVLED INTO CNTNRS W/ NON-SPRKG TOOL.PVNT
RUN-OFF TO SEWERS,STREAMS,ETC.IF RUN-OFF OCCURS CALL AUTHORITIES
Other REC Limits:N/K (FP/N/ORNL)
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CORNEAL EFFECTS MAY OCCUR OVER
TIME.NIOSH STUDIES INDICATE 2-BUTOXYETHANOL HAS CAUSED REPRODUCTIVE
DISORDERS IN LABORATORY ANIMALS AND MAY HAVE THE POTENTIAL FOR
CAUSING SIMILAR DISORDERS IN HUMANS (F P N).BRAIN AND NERVOUS
SYSTEM DAMAGE.INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING AND
INHALING CONTENTS (SEE SUPP)
Explanation of Carcinogenicity:N/K
Effects of Overexposure:EYES:SEVERE IRRITATION,REDNESS,TEARING,BLURRED
VISION.SKIN:MODERATE
IRRITATION,DEFATTING,DERMATITIS.INGESTION:BURNING
SENSATION,NAUSEA,VOMITING,DIARRHEA.INHALATION:NASAL AND RESPIRATORY
IRRITATION,DIZ
ZINESS,WEAKNESS,FATIGUE,NAUSEA,HEADACHE,UNCONSCIOUSNESS,AND EVEN
ASPHYXIATION.
Medical Cond Aggravated by Exposure:N/K
* First Aid Measures *
ATTN.SKIN:WASH AREA W/ SOAP & H*2O.REMOVE SOILED CLTHG & WASH
BEFORE REUSE.GET MED ATTN IF IRRIT PERSISTS.INGEST:GET MED ATTN
IMMED.DO NOT IN DUCE VOMIT.ASPIRATION CAN CAUSE CHEMICAL
PNEUMONITIS WHICH MAY BE FATAL.INHALATION.IF DFCLT BRTHG,REMOVE TO
FRESH AIR.IF BRTHG STILL DFCLT GET MED ATTN.IF BRTHG STOPS RESTORE
W/ ARTIF RESP & GET MD.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:N/K
Extinguishing Media:DRY CHEMICAL OR FOAM.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .SUMMON PROFESSIONAL FIREFIGHTERS.
Unusual Fire/Explosion Hazard:KEEP AWAY FROM HEAT,SPARKS,AND FLAME.DO
NOT SMOKE.EXTINGUISH ALL PILOT LIGHTS AND ALL OTHER SOURCES OF
IGNITION,INCLUDING HEATERS,FANS AND ALL OTHER (SEE SUPP)
* Accidental Release Measures *
Spill Release Procedures:SMALL SPILL:ABSORB LIQUID ON INERT MATERIAL
AND TRANSFER TO HOOD.LGE SPILL:ELIM ALL IGNIT SOURCES.PERSON W/OUT
PROTECTIVE EQUIP SHOULD LEAVE.STOP SPILL AT SOURCE.CONTAIN AREA OF
SPILL.PUMP LIQUID INTO SALVAGE TANK.REMAINING LIQUID MAY BE (SEE
SUPP)
Neutralizing Agent:N/K
*Handling and Storage *
Handling and Storage Precautions:KEEP CLOSURE TIGHT & UPRIGHT TO PRVNT
LEAKAGE.KEEP CONTR CLOSED WHEN NOT IN USE.DO NOT STORE ABOVE
Other Precautions:CONTAINERS OF THIS MATERIAL MAY BE HAZARDOUS WHEN
EMPTIED BECAUSE THEY RETAIN PRODUCT RESIDUES (VAPOR,LIQUID,AND/OR
SOLID).ALL HAZARD PRECAUTIONS MUST BE OBSERVED.
* Physical/Chemical Properties *
Melt/Freeze Pt:M.P/F.P Text:N/K
Decomp Temp:Decomp Text:N/K
Vapor Pres:N/K
Vapor Density:>1 (AIR=1)
Spec Gravity:1.8 (WATER=1)
Evaporation Rate & Reference:<1 (ETHER=1)
Solubility in Water:N/K
Appearance and Odor:N/K
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIALS.CHLOROFORM,POTASSIUM-TERT-BUTOXIDE,CHLOROSULFONIC
ACID,HYDROGEN PEROXIDE,NITRIC ACID.
Stability Condition to Avoid:EXCESS HEAT.
Hazardous Decomposition Products:TOXIC FUMES.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
* Disposal Considerations *
Waste Disposal Methods:ALLOW VOLATILE PORTION TO EVAPORATE IN
HOOD.DISPOSE OF CONTAMINATED ABSORBENT,CONTAINER AND UNUSED
CONTENTS IN ACCORDANCE WITH LOCAL,STATE AND FEDERAL REGULATIONS.DO
NOT INCINERATE CLOSED CONTAINERS.
| 1 | eyes_protection_mandatory |
Control Measures
*
Cage: 0FTL5
Proprietary Ind: Y
*
Preparer Co. when other than Responsible Party Co.
*
Cage: 0FTL5
*
Contractor Summary
*
Cage: 0FTL5
*
Ingredients
*
-----------------------------
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: NO
Skin: NO
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: EYES: MAY CAUSE BURNING & IRRITATION. SKIN: MAY CAUSE
IRRITATION/DERMATITIS. INGESTION: MAY CAUSE IRRITATION.
Explanation Of Carcinogenicity: NONE
Signs And Symptions Of Overexposure: IRRITATION, BURNING, HEADACHE, DIZZINESS,
DROWSINESS, NAUSEA, GASTRIC DISTURBANCES.
Medical Cond Aggravated By Exposure: SOME SKIN DISORDERS, SUCH AS DERMATITIS.
& WATER. INHALATION: REMOVE TO FRESH AIR. GIVE CPR/OXYGEN IF NEEDED.
INGESTION: DON'T INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN AL L CASES.
*
Handling and Disposal
*
Spill Release Procedures: WIPE UP. DISPOSE OF WIPERS IN CONTAINERS APPROVED FOR
OILY WASTE. PREVENT RUN-OFF TO SEWERS, STREAMS/OTHER WATERWAYS.
Waste Disposal Methods: DISPOSE OF IN LANDFILL/INCINERATION IAW/FEDERAL, STATE
& LOCAL REGULATIONS.
Handling And Storage Precautions: KEEP CONTAINERS CLOSED WHEN NOT IN USE. KEEP
AWAY FROM EXCESSIVE HEAT, SPARKS, OPEN FLAMES. FOR COMMERCIAL/INDUSTRIAL USE
ONLY.
Other Precautions: DON'T REUSE CONTAINERS. KEEP FROM REACH OF CHILDREN.
*
Fire and Explosion Hazard Information
*
Extinguishing Media: FOAM, CO2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures: WATER MAY BE INEFFECTIVE, BUT CAN BE USED TO COOL
CONTAINERS EXPOSED TO HEAT/FLAME.
Unusual Fire/Explosion Hazard: DENSE SMOKE MAY BE GENERATED WHILE BURNING. INK
SOILED CLOTHES MAY BE SUBJECT TO SPONTANEOUS COMBUSTION.
*
*
Respiratory Protection: NOT NORMALLY REQUIRED.
Ventilation: GENERAL VENTILATION AS PER LOCAL/STATE REGULATIONS.
Other Protective Equipment: APRON, BOOTS, IMPERVIOUS CLOTHING
Work Hygienic Practices: WASH THOROUGHLY AFTER HANDLING.
*
Physical/Chemical Properties
*
Vapor Density: >1
Spec Gravity: >1
Solubility in Water: INSOLUBLE
Appearance and Odor: PROCESS BLUE COLORED PASTE.
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: EXCESS HEAT, SPARKS & OPEN FLAMES.
Materials To Avoid: STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products: BY FIRE: DENSE SMOKE & CO.
Hazardous Polymerization Indicator: NO
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
HAZCOM Label
*
Cage: 0FTL5
Company Name: AM MULTIGRAPHICS
Label Required IND: Y
Status Code: C
Origination Code: G
Hazard And Precautions: EYES: IRRITATION & BURNING. SKIN:
IRRITATION/DERMATITIS. INGESTION: IRRITATION.
IRRITATION, BURNING SENSATION,
HEADACHE, DIZZINESS, DROWSINESS, NAUSEA, GASTRIC DISTURBANCES.
*
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE AIRLINE RESPIRATOR UNLESS AIR SAMPLING SHOWS
EXPOSURE TO BE BELOW PEL. THEN, EITHER CHEMICAL CARTRIDGE
RESPIRATORS OR AIRLINE RESPIRATORS REQUIRED. USE SAME PRECAUTIONS
DURING MIXING OR ANY OPERAT IONS WHERE PAINT FUMES WOULD BE
PRESENT.
Ventilation:GENERAL DILUTION/LOCAL EXHAUST TO KEEP BELOW PEL/TLV DURING
MIXING, APPLICATION, CURING & REMOVE DECOMP PROD (WELD,CUT).
Other Protective Equipment:WEAR PROTECTIVE CLOTHING TO KEEP SKIN
CONTACT AT A MINIMUM.
Work Hygienic Practices:WASH HANDS AND ANY EXPOSED SKIN THOROUGHLY
BEFORE EATING OR SMOKING. SMOKE IN DESIGNATED AREAS ONLY.
Supplemental Safety and Health
* Product Identification *
Preparer's Name:JANE FREEMAN
* Composition/Information on Ingredients *
Ingred Name:METHYL ISOBUTYL KETONE (SOLVENT) (SARA III)
Other REC Limits:NONE SPECIFIED
Ingred Name:PREPOLYMER OF HEXAMETHYLENE DIISOCYANATE
Other REC Limits:.5 MG/M3;STEL 1MG/M3
Ingred Name:SILICA (PIGMENT)
Other REC Limits:NONE SPECIFIED
OSHA PEL:SEE TABLE Z3
Ingred Name:IRON OXIDE (PIGMENT) (NUISANCE DUST)
Fraction by Wt: 1.0-5.0%
Other REC Limits:NONE SPECIFIED
Ingred Name:METHYL ISOAMYL KETONE (SOLVENT)
Other REC Limits:NONE SPECIFIED
Ingred Name:XYLENE (SOLVENT) (SARA III)
Other REC Limits:NONE SPECIFIED
Ingred Name:TRIVALENT CHROME (SARA III)
Other REC Limits:NONE SPECIFIED
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:BUTYL ACETATE (SOLVENT) (SARA III)
Other REC Limits:NONE SPECIFIED
Ingred Name:HEXAMETHYLENE DIISOCYANATE MONOMER
Other REC Limits:NONE SPECIFIED
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
* Hazards Identification *
Reports of Carcinogenicity:NTP:UNKNOWN IARC:YES
Health Hazards Acute and Chronic:SKIN, EYE, RESP TRACT IRRIT. CHRONIC:
RESPIRATORY SENSITIZATION & SKIN SENSITIZATION. DERMATITIS.
PERMANENT BRAIN AND NERVOUS SYSTEM DAMAGE, LIVER AND KIDNEY DAMAGE.
LUNG INJURY.
Explanation of Carcinogenicity:IARC HAS LISTED SILICA AS A PROBABLE
HUMAN CARCINOGEN.
Effects of Overexposure:WATERING EYES, THROAT DRYNESS, COUGHING,
HEADACHE, CHEST TIGHTNESS/BURNING SENSATION. HEADACHE, DIZZINESS,
NAUSEA, RASH, ITCHING HIVES & SWELLING OF EXTREMITIES.
Medical Cond Aggravated by Exposure:ASTHMA AND OTHER RESPIRATORY
AILMENTS; CHEMICAL SENSITIZATION.
* First Aid Measures *
First Aid:INHALATION: REMOVE FROM EXPOSURE. RESTORE BREATHING. KEEP
WARM & QUIET. NOTIFY PHYSICIAN. EYES: FLUSH IMMEDIATELY WITH
PHYSICIAN. SKIN: WASH AFFECTED AREAS WITH SOAP & WATER. REMOVE
CONTAMINATED CLOTHING. WASH BEFORE REUSE. CONSULT PHYSICIAN IF
IRRITATION DEVELOPS/PERSISTS. INGESTION: CALL A PHYSICAN OR POISON
CONTROL CENTER IMMEDIATELY.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:1.0
Upper Limits:8.2
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL
Fire Fighting Procedures:FULL PROTECTIVE EQUIPMENT WITH SELF-CONTAINED
BREATHING APPARATUS. DURING FIRE, IRRITATING/HIGHLY TOXIC GASES &
SMOKE PRESENT FROM DECOMP/COMBUSTION PRODUCTS.
Unusual Fire/Explosion Hazard:KEEP CNTNR CLSD.KEEP FROM HEAT/IGNIT
SOURCE.CLSD CNTNR MAY EXPLODE W/HEAT,BURST WHEN CONTAM W/WATER.
DONT APPLY TO HOT SRFCS.NEVER CUT,WELD NEAR DRUM-EXPLOSIVE.
* Accidental Release Measures *
Spill Release Procedures:EVAC NON-ESSENTL PEOPLE.REMOVE IGNIT
SOURCE.VENT.AVOID BREATHING.COVER SPILL W/INERT ABSORB.POUR LIQ
OPEN CNTNR ADD DECONTAM SOLUTION.CO VER LOOSELY.WASH DOWN AREA
*Handling and Storage *
FROM IGNIT SOURCE. KEEP CONTAINER CLOSED.
Other Precautions:IF MOISTURE ENTERS, DONT RESEAL. DONT INGEST. GROUND
CONTAINERS WHEN POURING. AVOID LIQUID FREE FALL >FEW INCHES. USE
W/VENT & RESP EQUIP. EMPTIED CONTAINERS MAY RETAIN HZD RESIDUE.
FOLLOW PRECAUTIONS . AVOID EYE, SKIN, OR CLOTHING CONTACT.
* Physical/Chemical Properties *
HCC:F2
Vapor Density:> AIR
Evaporation Rate & Reference:FASTER THAN BUTYL ACETATE
Solubility in Water:REACTS WITH WATER
Appearance and Odor:OPAQUE LIQUID, SOLVENT ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
WATER, ALCOHOLS, GLYCOL ETHERS, AMINES
Stability Condition to Avoid:CONTAMINATION WITH WATER
Hazardous Decomposition Products:CO2, CO, OXIDES OF NITROGEN, TRACES OF
HYDROGEN CYANIDE, HEXAMETHYLENE DIISOCYANATE.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. INCINERATION IS PREFERRED METHOD OF DISPOSAL.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR A POSITIVE PRESSURE SUPPLIED AIR
HISTORY OF LUNG/BREATHING PROBLEMS/REACTION TO ISOCYANATES
SHOULDN'T USE/BE EXPOSED TO PRODUCT.
Ventilation:SUFFICIENT IN VOLUME & PATTERN TO KEEP CONTAMINANTS BELOW
APPLICABLE OSHA LIMITS.
Other Protective Equipment:COVERALLS.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING & BEFORE
EATING/SMOKING.
Supplemental Safety and Health
CONTAINER & DISPOSE OF MATERIAL.
* Product Identification *
Preparer's Name:T R LOUER
* Composition/Information on Ingredients *
Ingred Name:ACRYLIC POLYMER RESIN
Ingred
Name:BETA-(3-(2H-BENZOTRIAZOLE-2-YL)-4-HYDROXY-5-TERT-BUTYLPHENYL)
PROPIONATE
Ingred Name:HINDERED AMINE
Ingred Name:2-HEPTANONE, METHYL N-AMYL KETONE
Fraction by Wt: 5%
Ingred Name:PROPYLENEGLYCOL MONOMETHYL ETHER ACETATE,
1-METHOXY-2-PROPANOL ACETATE
Ingred Name:VOLATILE ORGANIC CONTENT: 3.7 LBS/GAL
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: MAY CAUSE NOSE & THROAT
IRRITATION. EXPOSURE TO ISOCYANATES MAY CAUSE RESPIRATORY
SENSITIZATION & MAY CAUSE A DECREASE IN LUNG FUNCTION WHICH MAY BE
PERMANENT. EYES: IRRITATION/BURNING. SK IN: IRRITATION &
DERMATITIS. REPEATED/PROLONGED OVEREXPOSURE TO SOLVENTS MAY CAUSE
PERMANENT BRAIN & CNS DAMAGE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:GI DISTRESS, IRRITATION, EYE WATERING,
HEADACHES, NAUSEA, DIZZINESS, LOSS OF COORDINATION, BURNING,
DISCOMFORT.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. EYES: FLUSH W/PLENTY OF
ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Flash Point Method:CC
Lower Limits:0.2
Extinguishing Media:WATER SPRAY, FOAM, CO2, DRY CHEMICAL.
Fire Fighting Procedures:USE FULL PROTECTIVE EQUIPMENT & SCBA. WATER
FROM FOG NOZZLES MAY BE USED TO COOL CLOSED CONTAINERS.
Unusual Fire/Explosion Hazard:WHEN HEATED ABOVE THE FLASHPOINT, EMITS
FLAMMABLE VAPORS, WHEN MIXED W/AIR CAN BURN/BE EXPLOSIVE. FINE
MISTS/SPRAYS MAY BE FLAMMABLE AT TEMPS < THE FLASHPOINT.
* Accidental Release Measures *
Spill Release Procedures:DON'T BREATHE VAPORS. DON'T GET IN EYES/ON
SKIN. WEAR A POSITIVE PRESSURE SUPPLIED AIR VAPOR/PARTICULATE
OF IGNITION. ABSORB W/INERT MATERIAL. VENTILATE AREA. (SEE SUPP)
*Handling and Storage *
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS & FLAME.
CLOSE CONTAINER AFTER EACH USE. GROUND CONTAINERS WHEN POURING.
Other Precautions:DON'T SAND, FLAME CUT, BRAZE/WELD DRY COATING W/O A
NIOSH/MSHA APPROVED RESPIRATOR/APPROPRIATE VENTILATION. DON'T
BREATHE VAPORS. DON'T PERMIT ANYONE W/O PROTECTION IN THE PAINTING
AREA.
* Physical/Chemical Properties *
Vapor Density:>1
Evaporation Rate & Reference:LESS THAN ETHER
Solubility in Water:MISCIBLE
Percent Volatiles by Volume:(SUPP)
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE REASONABLY FORSEEABLE.
Hazardous Decomposition Products:CO, CO2, SMOKE.
* Disposal Considerations *
Waste Disposal Methods:INCINERATE/DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS. DON'T ALLOW MATERIAL TO CONTAMINATE GROUND WATER
SYSTEMS. DON'T INCINERATE IN CLOSED CONTAINERS. FLAMMABLE LIQUID
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:UNDER NORMAL USE, NO RESPIRATORY PEOTECTION IS
REQUIRED WHEN USING THIS CHEMICAL. NIOSH/MSHA APPROVED SELF
CONTAINED BREATHING APPARATUS (SCBA) IS REQUIRED IF A LARGE SPILL
OR RELEASE OCCURS.
Ventilation:NORMAL VENT FOR STD MFRING PROC IS GENERALLY ADEQ. LOC
EXHST SHOULD BE USED WHEN LG AMTS ARE RELS. MECH VENT (SUPP DATA)
Other Protective Equipment:ANSI APPROVED EMERGENCY EYE WASH AND DELUGE
SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
ARE REQ FOR COMBUSTIBILITY. HAZ DECOMP PRODS:POSS CARBONYL FLU
VENT:SHOULD BE USED IN LOW PLACES.
* Product Identification *
Product ID:1,1,1,2-TETRAFLUOROETHANE
Preparer's Name:T. NAPRAVA
* Composition/Information on Ingredients *
Ingred Name:1,1,1,2-TETRAFLUOROETHANE
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:EFTS OF OVEREXP:HAVE CARCIN/MUTAGENIC EFTS. EMBRYOTOX
ACTIVITY HAS BEEN OBSERVED IN SOME ANIMAL TESTS BUT ONLY (ING 3)
Ingred Name:ING 2:AT MATERNALLY TOX DOSE LEVELS. HUMAN HLTH EFTS FROM
OVEREXP BY INHAL MAY CAUSE TEMPORARY ALTERATION OF (ING 4)
Ingred Name:ING 3:HEART'S ELECTRICAL ACTIVITY W/IRREG PULSE,
PALPITATIONS/INADEQ CIRCULATION. SKIN CONT W/LIQ MAY CAUSE
FROSTBITE.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL HIGH CONCS OF VAP IS HARMFUL &
MAY CAUSE LT-HEAD, SHORTNESS OF BRTH, HEART IRREGS, UNCON/DEATH.
VAP IS HVR/AIR & MAY REDUCE OXYG AVAIL FOR BRTHG. INTENTIONAL
MISUSE CAN BE FATAL. THIS CHEM IS UN TESTED FOR ANIMAL SENSIT &
SKIN & EYE IRRIT. NO TOX EFTS WERE SEEN IN ANIMALS BY INHAL TO
CONCS UP TO (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
NOT (ING 2)
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH PREEXISITING
DISEASES OF THE CENTRAL NERVOUS SYSTEM OR CARDIOVASCULAR SYSTEM MAY
HAVE INCREASED SUSCEPTIBILITY TO THE TOXICITY OF EXCESSIVE
EXPOSURES.
* First Aid Measures *
First Aid:INGEST:CALL MD IMMED . INHAL:REMOVE TO FRESH AIR; KEEP CALM.
IF BRTHG IS DFCLT, GIVE OXYG. IF NOT BRTHG, GIVE ARTF RESP. CALL
MD. NOTE TO MD:BECAUSE OF POSS DISTURBS OF CARDIAC RHYTHM,
CATECHOLA MINE DRUGS, SUCH AS EPINEPHRINE, SHOULDONLY BE USED
W/SPECIAL CAUTN IN SITUATIONS OF EMER LIFE SUPPORT. SKIN:FLUSH
W/PLENTY OF WATER. GET MED ATTN IF IRRIT IS PERSISTANT. EYES:IMMED
FLUSH (SUPP DATA)
* Fire Fighting Measures *
Flash Point:NONE.
Extinguishing Media:USE EXTINGUISHING MEDIA AS APPROPRIATE FOR
COMBUSTIBLES.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . USE WATER SPRAY OR FOG TO COOL CONTAINERS.
Unusual Fire/Explosion Hazard:CYLS MAY RUPTURE UNDER FIRE CNDTNS.
* Accidental Release Measures *
Spill Release Procedures:VENTILATE AREA. USE NIOSH/MSHA APPROVED SELF
CONTAINED BREATHING APPARATUS (SCBA) IN CASE OF LARGE SPILLS.
COMPLY WITH FEDERAL, STATE AND LOCAL REGULATIONS ON REPORTING
RELEASES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:AVOID BREATHING VAPORS AND PROLONGED
SKIN EXPOSURE. USE WITH SUFFICIENT VENTILATION TO KEEP EXPOSURE
BELOW RECOMMENDED LIMITS.
Other Precautions:DO NOT MIX WITH AIR FOR LEAK TESTING OR USE WITH AIR
FOR ANY PURPOSE ABOVE ATMOSPHERIC PRESSURE.
* Physical/Chemical Properties *
Vapor Pres:SUPP DATA
Vapor Density:SUPP DATA
pH:NEUT
Evaporation Rate & Reference:>1 (COL*4=1)
Appearance and Odor:CLEAR AND COLORLESS LIQUIFIED GAS WITH A SLIGHTLY
ETHEREAL ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ALKALI OR ALKALINE EARTH METALS (POWDERED AL, ZN, BE, ETC).
Stability Condition to Avoid:AVOID OPEN FLAMES AND HIGH TEMPERATURES.
Hazardous Decomposition Products:MATL MAY DECOMP IF EXPOSED TO HIGH
TEMPS (OPEN FLAMES, GLOWING METAL SURFS, ETC) FORMING HYDROFLUORIC
ACIDS, & (SUP DAT)
* Disposal Considerations *
Waste Disposal Methods:COMPLY WITH FEDERAL, STATE AND LOCAL
REGULATIONS. REMOVE TO A PERMITTED WASTE DISPOSAL FACILITY.
| 1 | eyes_protection_mandatory |
Control Measures
*
Product ID: PERMATEX FORM-A GASKET NO 2 SEALANT, 2N
*
Contractor Summary
*
*
Ingredients
*
ACGIH TLV: 2 MG/M3 (MFR)
------------------------------
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
------------------------------
------------------------------
% Wt: 1-3
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: VAPOR ABOVE TLV IS IRRITATION TO EYES, NOSE, THROAT &
CAN CAUSE HEADACHE, DIZZINESS & NAUSEA. MODERATELY TOXIC BY INGESTION.
EYE IRRITANT. TARGET ORGANS & OTHER HEALTH EFFECTS:ING 1:BLOOD,
DEVELOPMENT AL. ING 2:ALLERGEN, LUNG. ING 4:GASTROINTESTINAL, IRRITANT,
NERVOUS SYSTEM, REPRODUCTIVE.
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: SKIN, EYE, RESPIRATORY DISORDERS.
First Aid: INGEST:DO NOT INDUCE VOMITING & GET MEDICAL ATTENTION.
INHAL:REMOVE TO FRESH AIR. CALL MD. SKIN:WASH W/LARGE QUANTITIES OF SOAP
*
Handling and Disposal
*
Spill Release Procedures: REMOVE SOURCES OF IGNITION. MAINTAIN ADEQUATE
VENTILATION. SCRAPE UP AS MUCH AS POSSIBLE & STORE IN A CLOSED CONTAINER
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS (FP N). INCINERATE FOLLOWING EPA & LOCAL REGULATIONS. RCRA
Handling And Storage Precautions: DO NOT STORE NEAR HEAT, SPARKS OR FLAME.
AVOID PROLONGED BREATHING OF VAPORS & CONTACT W/EYES. AVOID PROLONGED
SKIN CONTACT.
Other Precautions: NONE SPECIFIED BY MANUFACTURER.
*
Fire and Explosion Hazard Information
*
Flash Point Method: TCC
Lower Limits: 2%
Extinguishing Media: CO*2, DRY CHEMICAL, FOAM.
Fire Fighting Procedures: USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: NONE.
*
*
Respiratory Protection: NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE
OF CONCERN (FP N).
Ventilation: SUFFICIENT TO MAINTAIN VAPOR CONCENTRATION BELOW TLV.
Other Protective Equipment: EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET ANSI
DESIGN CRITERIA (FP N).
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: NONE SPECIFIED BY MANUFACTURER.
*
Physical/Chemical Properties
*
Spec Gravity: 1.5
Evaporation Rate & Reference: 7.7 (ETHER=1)
Solubility in Water: PARTIAL
Appearance and Odor: BLACK PASTE; ALCOHOLIC ODOR.
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: STRONG OXIDIZERS.
Hazardous Decomposition Products: HAZARDOUS PRODUCTS FORMED BY FIRE OR THERMAL
DECOMPOSITION: IRRITATING ORGANIC VAPORS.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
HAZCOM Label
*
Product ID: PERMATEX FORM-A GASKET NO 2 SEALANT, 2N
Company Name: LOCTITE CORP
Label Required IND: Y
Status Code: C
Origination Code: G
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: Severe
Reactivity Hazard: None
Hazard And Precautions: ACUTE:VAPOR ABOVE TLV IS IRRITATION TO EYES, NOSE,
THROAT & CAN CAUSE HEADACHE, DIZZINESS & NAUSEA. MODERATELY TOXIC BY
INGESTION. EYE IRRITANT. TARGET ORGANS & OTHER HEALTH EFFECTS:ING
1:BLOOD, DEVEL OPMENTAL. ING 2:ALLERGEN, LUNG. ING 4:GASTROINTESTINAL,
IRRITANT, NERVOUS SYSTEM, REPRODUCTIVE. CHRONIC:NONE LISTED BY MANUFACTURER.
*
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPRVD PROPERLY FITTED MECH
RESP/MASK TO AVOID BRTHG VAP/SPRAY MIST DURING MIX,SPRAYING,
AIR SUPP RESP IN CONFINED AREA S/WHEN OVERSPRAY IS PRESENT. (SUPP
DATA)
Ventilation:PROVIDE SUFF VENT IN VOL & PATTERN TO KEEP AIR CONTAM CONC
BELOW APPLIC OSHA PEL/ACGIH'S TLV LIMIT. FOR BAKING (SUPDAT)
Other Protective Equipment:PROTECTIVE OVERALLS RECOMMENDED.
Work Hygienic Practices:REMOVE AND WASH CONTAMINATED CLOTHING. DISCARD
CONTAMINATED SHOES.
Supplemental Safety and Health
EXPLO HAZ: PREC.DURING EMER CNDTNS, OVEREXP TO DECOMP PRODS MAY CAUSE
HLTH HAZ.OBTAIN MED ATTN.FIRST AID PROC:WHILE FLUSHING EYES,SEND
* Product Identification *
* Composition/Information on Ingredients *
Fraction by Wt: <5%
Ingred Name:MINERAL SPIRITS. VP: 5.
Ingred Name:MINERAL SPIRITS; (ODORLESS MINERAL SPIRITS). VP: 2.
Fraction by Wt: <5%
MG/KG.
Ingred Name:EFTS OF OVEREXP: STAG GAIT, CONFUSN, LOSS OF
CONSCIOUSNESS/COMA. EYE: CAN CAUSE SEV IRRIT & BLURRED VISION.
SKIN:(ING 6)
Ingred Name:ING 5:CAUSES IRRIT.PRLNGD/RPTD CONT MAY RSLT IN
DERM.NOTICE: RPTS HAVE ASSOC LRG SINGLE OVEREXP TO SOLV
W/KIDNEY,(ING 7)
Ingred Name:ING 6:LIVER & LUNG DMG.CHRONIC:ING 1:STUDIES SHOW PROD IS
BLOOD TOX.IN ADDN TO TARGENT ORGANS ALREADY MENTIONED, (ING 8)
Ingred Name:ING 7: STUDIES SHOW THAT PROD CAUSES DMG TO HEART IN
ANIMALS.LAB STUDIES SHOW XYLENE CAUSES EMBRYOTOXIC EFTS IN (ING 9)
Ingred Name:ING 8:RATS. ING 4:LAB STUDIES SHOW THAT INHAL EXPOS TO HIGH
Ingred Name:ING 9:RATS. THIS RESPONSE DID NOT OCCUR AT LOWER EXPOS LEVS
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: ING 1/ING 2/ING 3: INGEST:
ASPIR OF MATL INTO LUNGS DUE TO VOMIT CAN CAUSE CHEM PNEUM WHICH
CAN BE FATAL.DECISION TO INDUCE VOMIT MUST BE BASED ON MED ADVICE
FROM PHYS/POIS CNTRL CNTR. ING 4: I NGEST: LOW ORAL TOX. NO TOX
EFTS DUE TOINGEST ARE DESCRIBED IN LITERATURE. INHAL: IRRIT TO
UPPER RESP (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: TRACT. EYE:IRRIT. INGEST:CAUSES IRRIT
TO MOUTH, THROAT, & GI TRACT W/ACUTE CNS DEPRESS.SYMP MAY INCL
HDCH, DIZZ, CONFUSN, NAUS, VOMIT, ABDOMINAL PAIN,DIARR, LOSS OF
CONSCIOUSNESS/COMA. INHAL : ANESTHETIC. IRRIT OF RESP TRACT & ACUTE
NERV SYS DEPRESS CHARACT BY FOLLOWING PROGRESSIVE STEPS: HDCH,
DIZZ, (ING 5)
Medical Cond Aggravated by Exposure:NONE LISTED IN LITERATURE.
* First Aid Measures *
First Aid:INGEST: DRINK 1-2 GLASSES OF H*2O TO DILUTE.KEEP PERSON WARM,
QUIET & GET MED ATTN. IMMED: DECISION TO INDUCE VOMIT MUST BE BASED
ON ADVICE OF PHYS/POIS CNTRL CNTR. NEVER GIVE ANYTHING BY MOUTH TO
ANUNCON PERSON. INHAL: REMOVE FROM AREA TO FRESH AIR.RESTORE
BRTHG. CONSULT PHYS.EYE: IMMED BEGIN FLUSHING W/COOL H*2O,OCCAS
(SUPDAT)
* Fire Fighting Measures *
Lower Limits:1%
Extinguishing Media:FOAM, CO*2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT
EQUIP.H*2O MAY BE USED TO COOL CLSD CNTNRS TO PVNT PRESS BUILDUP &
POSS AUTOIGNIT/EXPLO WHEN EXPOS TO EXTREME HEAT
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM
HEAT, SPARKS, FLAME & ELEC EQUIP. CLSD CNTNRS MAY EXPLO WHEN EXPOS
TO EXTREME HEAT. APPLIC TO HOT SURFS REQS SPEC(SUPDAT)
* Accidental Release Measures *
Spill Release Procedures:REMOVE SOURCES OF IGNITION. SOAK UP AND REMOVE
WITH INERT ABSORBENT MATERIAL WITH NON-SPARKING TOOLS. PROVIDE
ADEQUATE VENTILATION. USE APPROVED VAPOR RESPIRATOR.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:STORE UPRIGHT IN SEALED CONTAINERS AND
USE AWAY FROM HIGH TEMPERATURE, SPARKS AND FLAME. AVOID PROLONGED
CONTACT WITH SKIN.
Other Precautions:DO NOT INGEST. KEEP CONTAINER TIGHTLY SEALED WHEN NOT
IN USE. KEEP OUT OF REACH OF CHILDREN.
FOR MED ASSIST.SKIN: WIPE OFF W/RAG & WASH THORO W/SOAP & H*2O.RE
SP PROT: CAREFULLY FOLLOW RESP MFR'S RECOM FOR USE.VENT: FINISHES,
VENT VAPORS EMITTED ON HEATING.
* Physical/Chemical Properties *
HCC:F4
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, ACIDS, BASES.
Stability Condition to Avoid:HIGH TEMPERATURE.
Hazardous Decomposition Products:MAY PRODUCE FUMES WHEN HEATED TO
DECOMPOSITION. FUMES MAY CONTAIN CO, CO*2, AND NO*2.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE IN SEALED METAL CONTAINER AWAY FROM HEAT
AND FLAME IN ACCORDANCE WITH LOCAL, STATE, AND FEDERAL REGULATIONS.
DO NOT INCINERATE CLOSED CONTAINERS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:RESPIRATORY PROTECTION IS NOT REQUIRED UNDER
NORMAL USE. USE NIOSH/MSHA APPROVED RESPIRATOR WHERE DUST, MIST, OR
SPRAY MAY BE GENERATED.
Ventilation:USE ADEQUATE LOCAL EXHAUST VENTILATION WHERE DUST, MIST, OR
SPRAY MAY BE GENERATED.
Other Protective Equipment:CHEMICALLY RESISTANT SHOES AND APRON. SAFETY
SHOWERS AND EYEWASH FACILITIES SHOULD BE ACCESSIBLE.
Work Hygienic Practices:WASH CONTAMINATED CLOTHING WITH SOAP AND WATER,
AND DRY BEFORE REUSE. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
FIRST AID PROC: INHAL: GET PERSON OUT OF CONTAMINATED AREA TO FRESH
AIR. INGEST: NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
IF SWALLOWED, DO NOT INDUCE VOMITING. GIVE LARGE QUANTITIES OF W
ATER. IF VOMITING OCCURS SPONTANEOUSLY,KEEP AIRWAY CLEAR. SEEK MD
ATTENTION IMMEDIATELY.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:NON-HAZARDOUS INGREDIENTS
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL:COUGHING/SNEEZING/OTHER SYMPS OF
UPPER RESP TRACT IRRIT MAY OCCUR.SEV EXPOS MAY RESULT IN LUNG TISS
DAM.SKIN:DRY PROD CAN BE AN IRRITANT. EYE:DRY PROD CAN CAUSE TISS
DESTRUCTION & PERM EYE DAM I F NOT TREATED IMMED.INGEST:DRY PROD
IRRITATES MUC MEMB OF MOUTH/THROAT/ESOPHAGUS & STOM.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:IRRITATES THE MUCOUS MEMBRANES OF THE
RESPIRATORY TRACT, MOUTH, THROAT, ESOPHAGUS, AND STOMACH. CAN ALSO
CAUSE PERMANENT EYE INJURY.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
HOLDING LIDS APART TO ENSURE FLUSHING OF ENTIRE SURF. WASHING W/IN
1 MIN IS ESSENTIAL TO ACHIEVE MAX EFTIVENESS. SEEK MD ATTN IMMED.
FOOTWEAR, & WASH CLTHG BEFORE REUSE. DISCARD ANY PIECE OF
CLTHG/FOOTWEAR THAT CANNOT BE DECONTAMD. SEEK MD ATTN IF SYMPS ARE
PRESENT. (SUPP DATA)
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:WATER, WATER FOG, CO*2, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:THERMAL DECOMPOSITION WILL RESULT IN THE
RELEASE OF POTENTIALLY DANGEROUS NO*X VAPORS.
* Accidental Release Measures *
Spill Release Procedures:SPILLED MATERIAL MAY BE SHOVELED UP, AND
STORED IN CLOSED CONTAINERS FOR POSSIBLE NORMAL USE OR PROPER
DISPOSAL. FLUSH AREA WITH PLENTY OF WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:AVOID CONT W/SKIN AND EYES. WASH
THOROUGHLY AFTER HANDLING. STORE IN A COOL, DRY AREA IN A CLOSED
CONTAINER. KEEP CNTNR TIGHTLY CLSD WHEN NOT IN USE.
Other Precautions:CONTAINERS, EVEN THOSE THAT HAVE BEEN EMPTIED, WILL
RETAIN PROD RESIDUE AND VAPORS. ALWAYS OBEY HAZARD WARNINGS AND
HANDLE EMPTY CONTAINERS AS IF THEY WERE FULL. CONTAINERS MUST NOT
BE USED FOR ANY OT HER PURPOSE.
* Physical/Chemical Properties *
HCC:N1
Solubility in Water:INSOLUBLE
Appearance and Odor:OFF-WHITE CRYSTALLINE POWDER
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
BASE. GRINDING/MIXING MATL IN THE PRESENCE OF DRY ALKALI (E.G.,
SODIUM/POTASSIUM HYDROXIDE) MAY CAUSE AUTOIGNITION.
Stability Condition to Avoid:AVOID OPEN FLAMES OR OTHER HIGH
TEMPERATURE SOURCES WHICH MIGHT CAUSE THERMAL DECOMPOSITION.
Hazardous Decomposition Products:THERMAL DECOMPOSITION WILL RESULT IN A
RELEASE OF NO*X VAPORS.
* Disposal Considerations *
Waste Disposal Methods:WASTE SHOULD NOT BE DISCHARGED DIRECTLY INTO
SEWERS OR STREAMS. NEUTRALIZE TO A LOCALLY ACCEPTABLE PH, DEPENDING
ON USAGE AND LOCALITY. MAY ALSO REQUIRE PRECIPITATION AND
FILTRATION OF HEAVY METALS. D ISP MUST BE I/A/W FED, STATE & LOCAL
REGS .
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR NIOSH APPRVD RESP DESIGNED TO REMOVE
COMBINATION OF PARTICULATES & VAP. WHEN APPLYING SELECT APPROP RESP
PROT FOR CNDTNS. IN CONFINED/RESTRICTED VENT AREAS USE NIOSH APPRVD
AIR-LINE RESPS/HOODS. FOR MORE SPEC INFO CONT NEHC .
Ventilation:IMPLEMENT ADMIN & ENGINEERING CTLS. PROVIDE SUFFICIENT VENT
IN VOL & PATTERN. FOR MORE SPEC INFO CONT NEHC .
Other Protective Equipment:ANSI APPRVD EYE WASH FOUNTAIN & DELUGE
SHOWER . RESIST COVERALLS & SHOE COVERINGS. USE EXPLO & SPARK-PROOF
EQUIP.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING & BEFORE EATING,
SMOKING OR USING TOILET. LAUNDER CONTAMINATED CLOTHING BEFORE USE.
Supplemental Safety and Health
EXPLO HAZ:HEAT & OPEN FLAME. VAPS MAY SPREAD LONG DISTS, CAUSE FLASH
FIRES/IGNITE EXPLOSIVELY. EFTS OF OVEREXP:LIST OF OCCUP CHEM REPRO
HAZS. SEEK CONSULTATION FROM APPROP HLTH PROFESSIONALS CONCERNIN G
LATEST HAZ LIST INFO & SAFE HNDLG & EXPOS INFO . SPILL PROC:NOTIFY
LOC AUTHS. EYE PROT:FULL LGTH FSHLD .
* Product Identification *
Kit Part:Y
Preparer's Name:H.KLINE
CAGE:0Y2E4
CAGE:0Y2E4
* Composition/Information on Ingredients *
Ingred Name:TITANIUM DIOXIDE (CONTAINING 2 & 3)
Ingred Name:ALUMINUM HYDROXIDE
Fraction by Wt: <6%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:AMORPHOUS SILICA
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SILICA, CRYSTALLINE - QUARTZ; (SILICA (QUARTZ))
OSHA PEL:0.1 MG/M3 (MFR)
ACGIH TLV:0.1 MG/M3 RDUST
Fraction by Wt: <0.1%
OSHA PEL:0.5 MG/M3
ACGIH TLV:N/K
Fraction by Wt: <0.1%
OSHA PEL:N/K
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Fraction by Wt: <0.1%
OSHA PEL:0.2 MG/M3 DUST
Fraction by Wt: <0.1%
OSHA PEL:N/K
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Fraction by Wt: <0.1%
OSHA PEL:0.5 MG/M3
ACGIH TLV:0.5 MG/M3 (SB)
Fraction by Wt: <0.1%
ACGIH TLV:0.1 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Fraction by Wt: <0.1%
OSHA PEL:0.2 MG/M3
ACGIH TLV:0.2 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Fraction by Wt: <0.1%
OSHA PEL:0.1 MG/M3, C
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:TALC (POWDER), CONTAINING NO ASBESTOS FIBERS; (MAGNESIUM
ACGIH TLV:2 MG/M3 RDUST
Fraction by Wt: <0.1%
OSHA PEL:N/K
ACGIH TLV:0.1 MG/M3 RDUST
Ingred Name:AMORPHOUS SILICA GEL; (SILICA (AMORPHOUS))(ALTERNATE CAS
Fraction by Wt: <5%
OSHA PEL:6 MG/M3 (MFR)
ACGIH TLV:3 MG/M3 (MFR)
Fraction by Wt: <0.1%
OSHA PEL:N/K
Ingred Name:SOLVENT NAPHTHA (PETROLEUM), LIGHT AROMATIC; (HIGH FLASH
ACGIH TLV:N/K
Fraction by Wt: <0.1%
OSHA PEL:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
Fraction by Wt: <0.1%
OSHA PEL:5 PPM, S
ACGIH TLV:2 PPM, S
Fraction by Wt: <0.1%
OSHA PEL:0.5 PPM
ACGIH TLV:0.1 PPM
Ingred Name:PGE. %:6 PPM.
Fraction by Wt: <0.1%
ACGIH TLV:1 PPM, S
Ingred Name:BENZENE, 1,2,4-TRIMETHYL-; (1,2,4-TRIMETHYLBENZENE) (SARA
Fraction by Wt: 5.5%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:VAP/SPRAY MIST/SPATTERED MATL CAN BE
HARMFUL. RPTD & PRLNG OCCUP OVEREXP TO SOLVS IS ASSOC W/PERM BRAIN
& NERV SYS DMG. INTENTIONAL MISUSE/OTHER MASSIVE EXPOS TO SOLVS MAY
CAUSE MULTIPLE ORG DMG &/OR DEATH. SKIN:IRRIT; DEFAT & DRYING.
SENSIT/ALLERGIC RXN (RASH/HIVES). CAN BE ABSORBED. INHAL:IRRIT TO
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-QUARTZ:IARC
Effects of Overexposure:HLTH HAZ:NOSE & THROAT; HDCH, NAUS/DIZZ. LUNG
INJURY. CNS DMG. SILICOSIS. SMOKING AGGRAVATES PROBS. CHEM PNEUM.
IRREG HEARTBEAT. EYES:IRRIT. INGEST:HARMFUL. ASPIR CAN DMG LUNGS &
CAUSE CHEM PNEUM. TAR GET ORGS:KIDNEYS, LIVER, LUNGS, HEART, SKIN,
EYES, STOM, CNS, FETAL DEFECTS. NOTE:LEAD & MERCURY APPEAR ON NAVY
(SUPDAT)
Medical Cond Aggravated by Exposure:SKIN, EYES, RESPIRATORY, ALLERGIES,
LUNGS.
* First Aid Measures *
First Aid:INHAL:REMOVE TO FRESH AIR. RESTORE NORMAL BREATHING. TREAT
SYMPTOMATICALLY. SEE MD. SKIN:WASH THORO W/SOAP & WATER. REMOVE
CONTAM CLTHG. CONSULT MD IF IRRIT PERSISTS. EYES:FLUSH IMMED
1-2 GLASSES OF WATER TO DILUTE. NEVER GIVE ANYTHING BY MOUTH TO
UNCON PERS. DO NOT INDUCE VOMIT. CONT MD/POIS CTL CTR IMMED. TREAT
SYMTOMATICALLY.
* Fire Fighting Measures *
Flash Point Method:SCC
Lower Limits:1%
Upper Limits:7%
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . WATER MAY BE USED TO COOL CLSD CNTNRS TO PREVENT PRESS
BUILD-UP/EXPLO WHEN EXPOSED TO EXTREME HEAT.
Unusual Fire/Explosion Hazard:COMBUST-CLASS II. FLAMM. CLSD CNTNRS MAY
EXPLODE WHEN EXPOS TO EXTREME HEAT & PRESS BUILDUP. MAY PRDCE
FLOATING FIRE HAZ. ISOLATE FROM ELEC EQUIP, SPKS,(SUPDAT)
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL SOURCES OF IGNIT. AVOID BRTHG VAPS.
VENT AREA. USE ABSORB, INERT, CLEANUP MATLS. (DO NOT USE SAWDUST.)
REMOVE ABSORB MATL W/NON-SPARKING TOOLS. PLACE IN SEPARATE CNTNR.
KEEP OUT OF SEWERS & WATERWAYS. IF ENTRY IS
THREATENED/OCCURS,(SUPDAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER CLOSED, UPRIGHT WHEN
NOT IN USE. STORE IN COOL, DRY, WELL-VENTILATED AREA. AVOID
Other Precautions:USE CAUTION WHEN POURING. AVOID BREATHING SANDING
DUST. DO NOT WELD OR FLAME CUT ON EMPTY CONTAINERS. DESTROY
CONTAMINATED LEATHER & ABSORBENT SHOES WHICH CANNOT BE
DECONTAMINATED. FOR INDUSTRIAL USEONLY.
* Physical/Chemical Properties *
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Evaporation Rate & Reference:0.1-0.6 (BUTYL ACETATE=1)
Appearance and Odor:LIQUID; SOLVENT ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, ACIDS, ALKALIES.
Stability Condition to Avoid:HEAT, OPEN FLAME, ARC OR SPARKS.
Hazardous Decomposition Products:BY FIRE, BURNING OR WELDING: CO, CO*2,
ALDEHYDES.
* Disposal Considerations *
Waste Disposal Methods:PLACE IN SEPARATE, APPROPRIATE, CLOSED CONTAINER
I/A/W ALL APPLICABLE LOCAL, STATE & FEDERAL REGULATIONS. THIS
MATERIAL HAS NOT BEEN TESTED BY TOXICITY CHARACTERISTIC LEACHING
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF ENGINEERING CONTROLS DO NOT MAINTAIN AIRBORNE
CONCENTRATIONS BELOW RECOMMENDED EXPOSURE LIMITS, AN APPROVED
RESPIRATOR MUST BE WORN. RESPIRATOR TYPE: DUST. IF RESPIRATORS ARE
USED, A PROGRAM SHOULD BE INSTITUTED.
HOUR, SHOULD BE USED. RATES SHOULD MATCH CONDITIONS.
Other Protective Equipment:CHEMICAL RESISTANT CLOTHING AS NECESSARY TO
PREVENT SKIN CONTACT. AN EMERGENCY EYEWASH AND SHOWER SHOULD BE
AVAILABLE.
Work Hygienic Practices:WASH HANDS THOROUGHLY WITH SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:TRISODIUM HYDROGEN ETHYLENE DIAMINE TETRAOCETATE
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE KIDNEY DAMAGE BASED ON
ANIMAL DATA. INHALATION MAY CAUSE IRRITATION TO THE MUCOUS
MEMBRANES AND UPPER RESPIRATORY TRACT. EYE CONTACT CAUSES BURNS.
SKIN CONTACT CAUSES IRRITATION. MAY BE HARM FUL IF SWALLOWED. MAY
CAUSE BURNS OF THE GASTROINTESTINAL TRACT IF SWALLOWED.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:KIDNEY DAMAGE, MUCOUS MEMBRANE IRRITATION,
UPPER RESPIRATORY TRACT IRRITATION, SKIN IRRITATION, EYE BURNS, GI
TRACT BURNS.
Medical Cond Aggravated by Exposure:
* First Aid Measures *
First Aid:INHALATION: IF SYMPTOMATIC, MOVE TO FRESH AIR. GET MEDICAL
ATTENTION IF SYMPTOMS PERSIST. EYES: WASH OUT IMEEDIATELY WITH
WATER. GET MEDICAL ATTENTION IF SYMPTOMS OCCUR. SKIN: WASH WITH
SOAP AND WATER . GET MEDICAL ATTENTION IF SYMPTOMS OCCUR.
INGESTION: CALL A PHYSICIAN OR POISON CONTROL CENTER IMMEDIATELY.
ONLY INDUCE VOMITING AT THE INSTRUCTION OF MEDICAL PERSONNEL. NEVER
GIVE ANYTHING BY MOUTH.
* Fire Fighting Measures *
Flash Point:COMBUSTIBLESOLID
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING. FIRE OR EXCESSIVE HEAT MAY PRODUCE HAZARDOUS
DECOMPOSITION PRODUCTS.
Unusual Fire/Explosion Hazard:POWDERED MATERIAL MAY FORM EXPLOSIVE
DUST-AIR MIXTURES.
* Accidental Release Measures *
Spill Release Procedures:FLUSH TO SEWER WITH LARGE AMOUNTS OF WATER, IF
ALLOWABLE. OTHERWISE, SWEEP UP AND PLACE IN A CONTAINER FOR
CHEMICAL WASTE. CLEAN SURFACE THOROUGHLY TO REMOVE RESIDUAL
CONTAMINATION.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:DO NOT GET IN EYES AND AVOID CONTACT
WITH SKIN AND CLOTHING. AVOID BREATHING DUST. USE WITH ADEQUATE
VENTILATION. KEEP FROM CONTACT WITH OXIDIZERS.
Other Precautions:MINIMIZE DUST ACCUMULATION. REFER TO NFPA PAMPHLET
DYE, PHARMACEUTICAL, AND PLASTICS INDUSTRIES."
* Physical/Chemical Properties *
HCC:F8
Boiling Pt:B.P. Text:NOT GIVEN
Vapor Pres:NEGLIGIBLE
Vapor Density:NOT GIVEN
Spec Gravity:NOT GIVEN
Evaporation Rate & Reference:NOT GIVEN
Appearance and Odor:WHITE SOLID, NO ODOR
Percent Volatiles by Volume:NIL
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, ACIDS.
Stability Condition to Avoid:
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
OXIDES OF NITROGEN, OXIDES OF SULFUR.
* Disposal Considerations *
Waste Disposal Methods:CAN BE INCINERATED WHEN IN COMPLIANCE WITH LOCAL
REGULATIONS. CONTRACT WITH A LICENSED CHEMICAL DISPOSAL AGENCY.
DISCHARGE, TREATMENT, OR DISPOSAL MAY BE SUBJECT TO NATIONAL, STATE
OR LOCAL LAWS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:AS REQUIRED
Ventilation:LOCAL EXHAUST/MECHANICAL/GENERAL
Other Protective Equipment:EYE WASH, SAFETY SHOWER
Work Hygienic Practices:WASH CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
* Product Identification *
Preparer's Name:GEORGE J. M
CAGE:TRUTE
CAGE:TRUTE
* Composition/Information on Ingredients *
Ingred Name:TETRASODIUM SALT OF ETHYLENEDIAMINETETRAACETIC ACID
SODIUM EDTA, SODIUM (DI) ETHYLENEDIAMINE TETRAACETATE
Fraction by Wt: 3-8%
Ingred Name:NONIONIC SURFACTANCT
Fraction by Wt: 2-8%
Ingred Name:GLYCOL ETHERS, DIETHYLENE GLYCOL, 2,2-OXYBISETHANOL
Fraction by Wt: 2-5%
Ingred Name:WEIGHT PER GALLON IN POUNDS: 8.6 LBS/GAL
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN: IRRITATION. INHALATION:
LUNG IRRITATION. INGESTION: HARMFUL & FATAL.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES/SKIN: IRRITATION. INHALATION: LUNG
IRRITATION. INGESTION: HARMFUL & FATAL.
* First Aid Measures *
WASH W/SOAP & WATER. INHALATION: REMOVE TO FRESH AIR. INGESTION:
DRINK WATER. DON'T INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:WATER
* Accidental Release Measures *
Spill Release Procedures:FLUSH W/WATER. PICK-UP & STORE IN SOUND DRUMS.
DON'T RELEASE INTO SEWERS.
*Handling and Storage *
Handling and Storage Precautions:FLOOR MAY BE SLIPPERY IF SPILLED. KEEP
CONTAINER CLOSED, KEEP FROM FREEZING. USE ADEQUATE VENTILATION &
AVOID BREATHING OF VAPORS.
Other Precautions:AVOID SKIN & EYE CONTACT. KEEP OUT OF REACH OF
CHILDREN. AVOID CONTACT W/FOOD. IF FROZEN, THAW & MIX BEFORE USE.
STORAGE STABILITY: OVER ONE YEAR.
* Physical/Chemical Properties *
Vapor Density:<1
Evaporation Rate & Reference:(BU AC = 1): <1
Solubility in Water:INFINITE
Appearance and Odor:CLEAR PINK LIQUID W/FLORAL ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ACIDS & BLEACH
Stability Condition to Avoid:FREEZING
Hazardous Decomposition Products:CO & CO2
* Disposal Considerations *
Waste Disposal Methods:LANDFILL IN ACCORDANCE W/LOCAL, STATE, & FEDERAL
REGULATIONS. BIODEGRADABLE.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:NO SPECIAL CONTROL MEASURES NECESSARY UNDER NORMAL
CONDITIONS OF USE.
Other Protective Equipment:NO SPECIAL PROTECTION NECESSARY.
Work Hygienic Practices:HANDLE IN ACCORDANCE WITH GOOD INDUSTRIAL
HYGIENE AND SAFETY PRACTICES.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
Preparer's Name:KENNETH C. PYLES
* Composition/Information on Ingredients *
Ingred Name:NON HAZARDOUS INGREDIENT
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN ABSORPTION: NO HAZARDS KNOWN TO
BORDEN. INGEST/INHAL: NO HAZARDS KNOWN TO BORDEN. SKIN: MAY CAUSE
IRRITATION ON PROLONGED OR REPEATED CONTACT. EYES: MAY CAUSE
IRRITATION ON PROLONGED OR REPEATED CONTACT.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:
* First Aid Measures *
First Aid:INGEST: IF ACCIDENTLY SWALLOWED, DILUTE BY DRINKING LARGE QTY
OF WATER. IMMED CONTACT POISON CONTROL CTR OR HOSP EMERGENCY ROOM
FOR ANY OTHER ADDITIONAL TRTMT DIRECTIONS. SKIN: FLUSH WITH WATER.
PHYS IF IRRIT PERSISTS. INHAL: REMOVE TO FRESH AIR. SUPPORT BRTHG.
(GIVE O*2/ARTF RESP) .
* Fire Fighting Measures *
Flash Point Method:SCC
Extinguishing Media:IN CASE OF FIRE, USE WATER SPRAY, DRY CHEMICAL,
"ALCOHOL" FOAM OR CO*2.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . USE WATER TO KEEP FIRE-EXPOSED CONTAINERS
COOL.
Unusual Fire/Explosion Hazard:WILL BURN.
* Accidental Release Measures *
Spill Release Procedures:LG QTY: ENCLOSE WITH DIKING MATERIAL TO
PREVENT SEEPAGE INTO NATURAL BODIES OF WATER, THEN CONSULT BORDEN,
INC. SM QTY: SOAK UP WITH ABSORBENT MATERIAL AND REMOVE TO CHEMICAL
DISPOSAL AREA.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTR CLSD. STORE IN COOL/DRY
PLACE. EMPTY CONTR MAY CNTN PROD RESIDUES. DO NOT CUT, TORCH/REUSE
W/OUT COMMERCIAL CLEANING. USE W/ADEQ VENT.
FROM ACIDS AND OXIDIZING AGENTS, HEAT, SPARKS, FLAME & OTHER
IGNITION SOURCES. AVOID PROLONGED OR REPEATED CONTACT WITH SKIN OR
EYES.
* Physical/Chemical Properties *
Vapor Density:7.5
Solubility in Water:6.1%
Appearance and Odor:CLEAR, WHITE TO LT YELLOW LIQUID ESTER.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZERS, ACIDS OR BASES.
Stability Condition to Avoid:WILL REACT WITH WATER AT HIGH
TEMPERATURES.
Hazardous Decomposition Products:DO NOT ADD ALPHACURE ESTERS TO DRUMS
CNTNG ALPHASET RESINS OR VICE VERSA. DECOMP PROD MAY INCL: OXIDES
OF CARBON.
* Disposal Considerations *
Waste Disposal Methods:RECOVER FREE LIQUID. ABSORB RESIDUE AND DISPOSE
OF ACCORDING TO LOCAL,STATE/PROVINCIAL, AND FEDERAL REQUIREMENTS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR W/ORGANIC VAPOR
CARTRIDGE.
Ventilation:USE IN AN AREA PROVIDED W/GENERAL & LOCAL EXHAUST
VENTILATION MEETING OSHA REQUIREMENTS.
Other Protective Equipment:EMERGENCY EYE WASH & DELUGE SHOWER .
PROTECTIVE CLOTHING MEETING LABORATORY SAFETY REQUIREMENTS.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRST AID PROC:GIVE FLUIDS/INDUCE VOMIT IF PERSON IS UNCONSCIOUS.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:METHANOL; (METHYL ALCOHOL)(SARA III)
Ingred Name:PHENOL-D6
Fraction by Wt: 1%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PHENOL, O-FLUORO-; (2-FLUOROPHENOL)
Fraction by Wt: 1%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PHENOL, 2,4,6-TRIBROMO; (2,4,6-TRIBROMOPHENOL)
Fraction by Wt: 1%
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:IRRITANT, HEADACHE, FATIGUE,
DILATED PUPILS, VISUAL DISTURBANCE, BLINDNESS, SHALLOW RESPIRATION,
RESPIRATORY FAILURE, CYANOSIS, CONVULSIONS, COMA, HYPOTENSION,
DEATH. CHRONIC:POSITIVE MUTAGEN. G ASTRO-INTESTINAL, LIVER, KIDNEY
& CARDIOVASCULAR SYSTEM INJURY, VISUAL IMPAIRMENT, DERMATITIS.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:NAUSEA, DROWSINESS, INTOXICATION, SEVERE
DEPRESSION, HEADACHE, VISUAL DISTURBANCE LEADING TO BLINDNESS,
COUGHING, SHORTNESS OF BREATH; BURNING, ITCHING, REDNESS OR
BLISTERS ON SKIN; BURNING, WATERING, SWELLING & REDNESS IN EYES.
Medical Cond Aggravated by Exposure:DERMATITIS, DISEASES OF EYES,
LIVER, KIDNEYS, LUNGS & CARDIOVASCULAR.
* First Aid Measures *
First Aid:EYES:REMOVE CONTACT LENSES IF PRESENT. HOLD EYELIDS OPEN &
SKIN:IMMED WASH W/SOAP & WATER. CONTINUE RINSING W/LG VOL OF WATER
TRAINED PERS ADMIN OXYGEN & CPR IF NEEDED. SEEK MED TREATMENT.
INGEST:DRINK LG VOLS OF WATER, THEN INDUCE VOMIT. DO NOT ATTEMPT TO
(SUPDAT)
* Fire Fighting Measures *
Lower Limits:6.7%
Extinguishing Media:DRY CHEMICAL, CO*2, HALON, ALCOHOL FOAM, WATER MIST
OR FOG.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROT EQUIP
. HEAT MAY BUILD PRESSURE & RUPTURE CLOSED STORAGE CNTNRS. KEEP
FIRE-EXPOS CNTNRS COOL W/WATER SPRAY.
Unusual Fire/Explosion Hazard:MAY FORM EXPLOSIVE VAPOR/AIR MIXTURES.
INCOMPLETE COMBUSTION MAY GENERATE TOXIC VAPORS.
* Accidental Release Measures *
Spill Release Procedures:WEAR PERSONAL PROTECTIVE EQUIPMENT. ABSORB
SMALL SPILLS ON PAPER, VERMICULITE OR OTHER ABSORBENT. COLLECT &
STORE IN CLOSED CONTAINER FOR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:AVOID ALL INHALATION & CONTACT. KEEP
IN A TIGHTLY CLOSED CONTAINER AT ALL TIMES. HANDLE W/UTMOST CARE.
STORE IN AN EXPLOSION PROOF REFRIGERATOR AT 4C.
Other Precautions:THIS PRODUCT IS FURNISHED FOR LABORATORY USE ONLY!
OUR STANDARDS MAY NOT BE USED AS DRUGS, COSMETICS, AGRICULTURAL OR
PESITICAL PRODUCTS, FOOD ADDITIVES OR AS HOUSEHOLD CHEMICALS.
* Physical/Chemical Properties *
HCC:F3
Solubility in Water:MISCIBLE
Appearance and Odor:COLORLESS; ALCOHOL ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZERS, REDUCING AGENTS, REACTIVE METALS.
Stability Condition to Avoid:HEAT, CONTACT W/IGNITION SOURCES.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
* Disposal Considerations *
Waste Disposal Methods:INCINERATE AT AN APPROVED FACILITY I/A/W
FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR SPECIFIED FOR
PROTECTION AGAINST PAINT SPRAY MIST & SANDING DUST IN RESTRICTED OR
CONFINED AREAS.
Ventilation:ADEQUATE TO MAINTAIN WORKING ATMOSPHERE BELOW TLV & LEL.
MECHANICAL EXHAUST MAY BE REQUIRED IN CONFINED AREAS.
Other Protective Equipment:CLOTHING ADEQUATE TO PROTECT SKIN.
Work Hygienic Practices:REMOVE & WASH CLOTHING BEFORE REUSE. WASH HANDS
BEFORE EATING, SMOKING OR USING THE WASHROOM.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:ZINC OXIDE
Fraction by Wt: 2.2% MAX
Ingred Name:SILICA, CRYSTALLINE - QUARTZ; (CRYSTALLINE SILICA). %:
Fraction by Wt: SEE ING
OSHA PEL:0.1 MG/M3 RDUST
ACGIH TLV:0.1 MG/M3 RDUST
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL:IRRITATION OF THE
RESPIRATORY TRACT. SKIN & EYE CONTACT:PRIMARY IRRITATION.
INGEST:INGESTION OF LARGE AMOUNTS COULD CAUSE SERIOUS INJURY.
CHRONIC:NONE KNOWN. ING 1:HAZARDOUS ONLY AS DUST W HEN PRODUCT IS
SANDED.
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-QUARTZ:IARC
ON CARCINS, (SUPDAT)
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE EXPECTED WHEN USED I/A/W SAFE
HANDLING & USE INFORMATION.
* First Aid Measures *
First Aid:INHAL:REMOVE TO FRESH AIR. GET MEDICAL HELP FOR ANY BREATHING
CALL MD. SKIN:WASH W/SOAP & WATER. INGEST:DRINK 1-2 GLASSES OF
WATER TO DILUTE. DO NOT INDUCE VOMITING. CALL MD.
* Fire Fighting Measures *
Flash Point Method:PMCC
Extinguishing Media:FOAM, CO2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . COOL EXPOSED CONTAINERS W/WATER.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY BURST IF EXPOSED TO
EXTREME HEAT OR FIRE. TOXIC GASES MAY FORM WHEN PRODUCT BURNS.
* Accidental Release Measures *
Spill Release Procedures:FLUSH W/WATER. ABSORB W/SAWDUST OR RAGS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:DO NOT THROW OR DROP CONTAINERS.
Other Precautions:AVOID CONTACT W/EYES & PROLONGED CONTACT W/SKIN OR
BREATHING OF SPRAY MIST OR SANDING DUST. CLOSE CONTAINER AFTER EACH
USE. KEEP OUT OF REACH OF CHILDREN. DO NOT TAKE INTERNALLY.
* Physical/Chemical Properties *
HCC:N1
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:SUPDAT
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE REASONABLY FORESEEABLE.
Stability Condition to Avoid:ELEVATED TEMPERATURES.
Hazardous Decomposition Products:BURNING MAY PRODUCE CARBON DIOXIDE &
CARBON MONOXIDE.
* Disposal Considerations *
Waste Disposal Methods:CONVENTIONAL PROCEDURES IN COMPLIANCE W/LOCAL,
STATE & FEDERAL REGULATIONS. DO NOT INCINERATE SEALED CONTAINERS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE NORMALLY NEEDED. USE NIOSH/MSHA APPROVED
FULL FACE MASK FITTED W/ORGANIC VAPOR CANISTER FOR CONCENTRATES
PPM OR LESS.
Other Protective Equipment:CLEAN AND PROTECTIVE CLOTHING TO AVOID SKIN
EXPOSURE.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
SPILL PROC: VENT UNTIL ALL VAPORS HAVE BEEN ELIMINATED. THEN THOROUGHLY
FLUSH AREA OF SPILL WITH WATER. WASTE DISP METH: TO PVNT ENVIRON
CONTAM. IT IS YOUR DUTY TO DISPOSE OF THE CHEM MATLS &/OR THEIR
CONTRS I/A/W THE CLEAN AIR ACT, THE CLEAN WATER ACT, THE RCRA & ALL
RELEVANT LOCAL, STATE, & FEDERAL REGS FOR DISPOSAL.
* Product Identification *
Preparer's Name:RICK GLISSON
* Composition/Information on Ingredients *
Ingred Name:NON HAZARDOUS INGREDIENTS
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:IRRITATION TO LUNGS (STRONG ODOR).
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:SKIN: FLUSH W/WATER. IF IRRITATION PERSISTS, CALL MD. EYES:
CALL MD. INGEST: IF CONSCIOUS, DRINK A QUART OF WATER & TAKE
ADRENALIN. M AY BE CONTRAINDICATED FOR OVEREXPOSURE TO
PARADICHLOROBENZENE. INHAL: REMOVE TO FRESH AIR. IF NOT BRTHG, GIVE
ARTF RESPIRATION/OXYGEN IF NECESSARY. CONTACT MD.
* Fire Fighting Measures *
Flash Point Method:CC
Extinguishing Media:DRY CHEMICAL, FOAM, CO2.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
* Accidental Release Measures *
Spill Release Procedures:REMOVE UNPROT PERS FROM AREA OF SPILL. PROVIDE
MAX VENT & REMOVE ALL IGNITION SOURCES. ONLY PERS EQUIPPED W/PROPER
RESP & EYE/SKIN PROT SHLD BE PERMITTED IN AREA. CAREFULLY
SHOVEL/SWEEP UP SPILLED MAT L & PLACE INTO CLOSED CONTRS. MAINTAIN
(SUPP DATA)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:ALWAYS STORE UNUSED PORTION IN
ORIGINAL CONTR W/CAP SECURE. NEVER STORE IN UNLABELED OR IMPROPERLY
LABELED CONTR. AVOID TEMPERATURE EXTREMES.
Other Precautions:AS W/ALL CHEMICALS, USE W/DUE CARE ACCORDING TO LABEL
INSTRUCTIONS & PRECAUTIONS. AVOID BREATHING VAPORS. KEEP OUT OF
REACH OF CHILDREN. FOR COMMERCIAL/INDUSTRIAL USE ONLY.
* Physical/Chemical Properties *
HCC:V4
Vapor Density:5.1
Appearance and Odor:ORANGE AND WHITE SOLID WITH FRUITY ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:OPEN FLAMES, HOT GLOWING SURFACES OR
ELECTRIC AREAS.
Hazardous Decomposition Products:HYDROGEN CHLORIDE & POSSIBLE TRACES OF
PHOSGENE.
* Disposal Considerations *
Waste Disposal Methods:MATL SHLD BE RECOVERED &/OR REPROCESSED.
OTHERWISE, IT MUST BE DISPOSED OF BY BURNING IN APPRVD INCINERATOR
OR BURIAL IN A PERMITTED HAZ WASTE MANAGEMENT FACILITY. CARE MUST
BE TAKEN WHEN USING OR DIS POSING OF CHEM MATLS &/OR THEIR CONTRS
(SUPP DATA)
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:SUPPLIED AIR W/FULL FACEPIECE,HELMET OR HOOD
Ventilation:LOCAL EXHAUST
Other Protective Equipment:FULL CLOTHING TO PREVENT SKIN CONTACT
Supplemental Safety and Health
OVEREXPOS:CAN CAUSE FORMATION OF CYSTS,CAUSES STILLBIRTHS.IRRITATES
EYES,NOSE THROAT.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:POLYCHLORINATED BIPHENYLS (PCBS) (SARA III)
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
* Hazards Identification *
Effects of Overexposure:ABSORBED THRU SKIN,LUNGS,INTESTINE.CAUSES
CANCER,LIVER,KIDNEY,STOMACH,EYE,HEARING DISORDER(SUP DATA)
* First Aid Measures *
First Aid:EYES:FLUSH W/WATER IMMEDIATELY.SKIN:WASH W/SOAP
IMMEDIATELY.INHAL:REMOVE TO FRESH AIR,GIVE ART.RESPIR.AS
NEEDED.INGEST:GET MEDICAL ATTN.GIVE LARGE QTY OF SALT WATER,INDUCE
VOMITING,BUT DO NOT MAKE UNC ONSCIOUS PERSON VOMIT.
* Accidental Release Measures *
Spill Release Procedures:USE ABSORBENT & DIKES TO PREVENT
RUNOFF.ISOLATE & NOTIFY PROPER AUTHORITIES.
*Handling and Storage *
Handling and Storage Precautions:STORAGE MUST FOLLOW RCRA REQUIREMENTS.
* Physical/Chemical Properties *
HCC:Z3
Appearance and Odor:LIGHT STRAW-COLORED LIQUID,AROMATIC ODOR
* Stability and Reactivity Data *
STRONG OXIDIZERS
* Disposal Considerations *
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-GENERALLY HIGH
TEMPERATURE INCINERATION.ONLY APPROVED DISPOSAL OPERATOR PERMITTED.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE PROTECTIVE EQUIPMENT IN ACCORDANCE WITH
USE SUPPLIED AIR RESP. IF VENT IS INADEQ OR SIGNIFICANT PROD EXPOS
IS LIKELY, USE NIOSH/MS HA APPRVD RESP W/DUST/MIST FILTERS.
Ventilation:ADEQUATE VENTILATION TO MAINTAIN AIR CONTAMINANTS BELOW
EXPOSURE LIMITS.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
NECESSARY.
Supplemental Safety and Health
FIRST AID PROCEDURES: PHYSICIAN DILUTE CONTENTS OF STOMACH USING 3-4
GLASSES MILK OR WATER.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:SODIUM HYDROXIDE (SARA III)
OSHA PEL:2 MG/M3
Ingred Name:1H-BENZOTRIAZOLE, METHYL-
Ingred Name:PHOSPHONIC ACID, (1-HYDROXYETHYLIDINE) BIS (HEDP)
Ingred Name:ACETIC ACID, (ETHYLENEDINITRILO) TETRA-, TETRASODIUM SALT;
(ETHYLENEDIAMINE TETRAACETIC ACID, TETRASODIUM SALT)
Ingred Name:SODIUM MOLYBDATE (VI)
OSHA PEL:5 MG/M3 (MO)
ACGIH TLV:5 MG/M3 (MO)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: SKIN: SLIGHTLY IRRITATING TO
SKIN. EYE: MODERATELY IRRITATING. INHALATION: MISTS/AEROSOLS MAY
CAUSE IRRITATION TO UPPER RESPIRATORY TRACT. CHRONIC: PROLONGED OR
REPEATED CONTACT MAY CAUSE PRIMA RY IRRITANT DERMATITIS.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:MAY CAUSE REDNESS OR ITCHING OF SKIN.
Medical Cond Aggravated by Exposure:NOT KNOWN.
* First Aid Measures *
First Aid:SKIN: REMOVE CONTAMD CLTHG. WASH EXPOSED AREA W/LRG QTY OF
TREATMENT. I NHAL: REMOVE VICTIM FROM CONTAMD AREA TO FRESH AIR.
APPLY APPROP FIRST AID TREATMENT AS NEC. INGEST: DO NOT FEED
ANYTHING BY MOUTH TO AN UNCON/CONVULS VICTIM. DO NOT INDUCE VOMIT.
IMMED CONT (SUPDAT)
* Fire Fighting Measures *
Flash Point Method:PMCC
Extinguishing Media:DRY CHEMICAL, CARBON DIOXIDE, FOAM OR WATER.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
* Accidental Release Measures *
Spill Release Procedures:VENT AREA. USE SPECIFIED PROT EQUIP. CONTAIN &
ABSORB ON ABSORB MATL. PLACE IN WASTE DISPOSAL CNTNR. WASTE CHARACT
OF ABSORBED MATL/ANY CONTAM SOIL. SHOULD BE DETERMINED I/A/W RCRA
REGS. FLUSH AREA W/ WATER. WET AREA MAY BE SLIPPERY.
SPREADSAND/GRIT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:KEEP DRUMS AND PAILS CLOSED WHEN NOT
IN USE. PROTECT FROM FREEZING. ALKALINE. DO NOT MIX WITH ACIDIC
MATERIAL.
Other Precautions:MAY BE TOXIC IF ORALLY INGESTED.
* Physical/Chemical Properties *
HCC:N1
Vapor Density:<1
Appearance and Odor:YELLOW LIQUID, SLIGHT ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:CONTAMINATION.
Hazardous Decomposition Products:THERMAL DECOMPOSITION (DESTRUCTIVE
FIRES) YIELDS ELEMENTAL OXIDES.
* Disposal Considerations *
Waste Disposal Methods:WATER CONTAMD WITH PRODUCT MAY BE SENT TO
SANITARY SEWER TREATMENT FACILITY IN ACCORDANCE WITH ANY FEDERAL,
STATE AND LOCAL AGREEMENT, A PERMITTED WASTE TREATMENT FACILITY OR
DISCHARGED UNDER NPDES PE RMIT. PROD (AS IS)-INCIN/BURY IN
APPRVDLANDFILL.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL AND GENERAL VENTILATION NECESSARY TO KEEP AIR
CONCENTRATION BELOW TLV .USE EXPLOSION-PROOF EQUIPMENT.
Other Protective Equipment:COMBINATION VAPOR/DUST RESPIRATOR (HAZARD
G,H,I,J).
Work Hygienic Practices:FOLLOW GOOD HOUSEKEEPING AND PERSONAL HYGIENE.
Supplemental Safety and Health
ROUTES OF ENTRY:EYES (MFR).
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:TOLUENE (SARA III)
Other REC Limits:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:REPORTS HAVE ASSOCIATED REPEATED AND
PROLONGED OCCUPATIONAL OVEREXPOSURE TO SOLVENTS WITH PERMANENT
BRAIN AND NERVOUS SYSTEM DAMAGE.INTENTIONAL MISUSE BY DELIBERATELY
CONCENTRATING AND INHALING THE CO NTENTS MAY BE HARMFUL OR FATAL.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES:IRRITATION.SKIN:IRRITATION.INGEST:N/K
.INHAL:HARMFUL,MAY AFFECT BRAIN OR NERVOUS SYSTEM CAUSING
DIZZINESS,HEADACHE,NAUSEA.CAUSES NOSE/THROAT IRRIT,BREATHING
DIFFICULTY,LIGHT-HEADEDNESS ,DRYNESS OF RESP TRACT.INTENTIONAL
MISUSE BY DELIBERATELY CONCENTRATING AND INHALING CONTENTS MAY BE
HARMFUL OR FATAL.
Medical Cond Aggravated by Exposure:ANY MEDICAL
CONDITION,ALLERGY,SENSITIZATION WHICH MAY BECOME WORSE UPON
EXPOSURE TO THE PRODUCT.
* First Aid Measures *
MIN.TAKE TO PHYSICIAN FOR TREATMENT.SKIN:WASH WITH SOAP &
WATER.REMOVE CONTAMINATED CLOTHING.CONSULT
PHYSICIAN.INGESTION:DILUTE BY DRINKIN G 2 GLASSES OF WATER.DO NOT
INDUCE VOMITING.CONSULT PHYSICIAN IMMEDIATELY.INHALATION:REMOVE TO
FRESH AIR,RESTORE BREATHING.CONSULT A PHYSICIAN.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:7.0%
Upper Limits:1.2%
Extinguishing Media:WATER SPRAY,ALCOHOL FOAM,DRY CHEMICAL,FOAM,CO*2,ANY
CLASS B EXTINGUISHING AGENT.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR,MAY TRAVEL
CONSIDERABLE DISTANCE TO A SOURCE OF IGNITION AND FLASHBACK.
* Accidental Release Measures *
Spill Release Procedures:ISOLATE,ABSORB & VENTILATE (OPEN ALL
WINDOWS,DOORS).REMOVE ALL IGNITION SOURCES,FLAMES,HOT
SURFACES.AVOID BREATHING OF VAPORS,USE RESP PROTECTIVE DEVICE.KEEP
PRODUCT OUT OF WATER COURSES (DRAINS,SEWER S) BY DIKING OR
IMPOUNDING.
Neutralizing Agent:N/K
*Handling and Storage *
Handling and Storage Precautions:AVOID HIGH TEMP.KEEP CLOSURE TIGHT &
CONTAINER UPRIGHT.DO NOT STORE OR USE NEAR
HEAT,SPARKS,FLAME.PREVENT PROLONGED/RPTD BREATHING OF VAP/SPRAY
MIST.
Other Precautions:DO NOT TAKE INTERNALLY.AVOID PROLONGED CONTACT WITH
SKIN.DO NOT GET IN EYES.
* Physical/Chemical Properties *
Decomp Temp:Decomp Text:N/K
Vapor Density:>1.0,AIR=1
Evaporation Rate & Reference:1.5 (BUTYL ACETATE=1)
Solubility in Water:NIL
Appearance and Odor:CLEAR LIQUID,AROMATIC ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE REASONABLY FORESEEABLE.
* Disposal Considerations *
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH
FEDERAL,STATE AND LOCAL REGULATIONS .BEFORE ATTEMPTING
CLEAN-UP,REFER TO HAZARD CAUTION INFORMATION.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:ANSI APPROVED EMERGENCY EYE WASH AND DELUGE
SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
MATLS TO AVOID:MAGNESIUM, ETC.), MAY CAUSE EXOTHERMIC RXN. ALUMINUM IN
REFRIGERATION SYS CNTNS AN OXIDE/CHLORIDE COATING SO IT DOES NOT
REACT. HAZ DECOMP PRODS:ENGINES, & OPEN FLAMES. DECOMP PRODS MAY
INCLUDE HYDROFLUORIC & HYDROCHLORIC ACIDS, CHLORINE, FLUORINE, POSS
PHOSGENE, CARBON DIOXIDE & MONOXIDE.
* Product Identification *
Preparer's Name:GEORGE GOBIE
CAGE:PEPLS
CAGE:PEPLS
* Composition/Information on Ingredients *
Ingred Name:PROPANE, 2-METHYL-; (ISOBUTANE)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ETHANE, 1-CHLORO-1,1-DIFLUORO; (1-CHLORO-1,1DIFLUOROETHANE)
OSHA PEL:N/K
ACGIH TLV:N/K
Ozone Depleting Chemical:2
Ingred Name:METHANE, CHLORODIFLUORO-; (CHLORODIFLUOROMETHANE) (SARA
Ozone Depleting Chemical:2
Ingred Name:FIRE FIGHT PROC:FLAM IF MIXED W/LG QTYS OF AIR @ GREATER
THAN ATM PRESS. IF CYLS OF PROD HAVE BEEN LEAKING (VAP (ING 5)
Ingred Name:ING 4:LEAK), REMAINING PROD MAY BECOME WEAKLY FLAM. HEAT OF
Ingred Name:ING 5:BUT NO FL PT. CYLS OF USED REFRIGERANT, MAY CNTN LG
AMTS OF REFRIGERATION (MINERAL) OIL. LIQ LEAK/CYL (ING 7)
Ingred Name:ING 6:VENTING IN FIRE WILL BRING OUT CLOUD OF OIL MIST.
THIS OIL MIST IS VERY FLAM (IN THE ORDER OF GASOLINE).
Ingred Name:EFTS OF OVEREXP:SENSIT TO EPINEPHRINE HAS BEEN OBSERVED @
Ingred Name:ING 8:HAVE PRDCED SENSIT OF MYOCARDIUM TO EPINEPHRINE IN
Ingred Name:ING 9:ADRENOMIMETICS (I.E., EPINEPHRINE) MAY BE
Ingred Name:FIRST AID PROC:PHYSICIAN. SKIN:FLUSH WITH WATER, WARM
SLOWLY (COOL WATER) IF FROSTBITE. CALL A PHYSICIAN.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL:VAP IS HVR/AIR & CAN CAUSE
SUFFOCATION BY DISPLACING OXYG AVAIL FOR BRTHG. CONT W/LIQ MAY
CAUSE FROSTBITE. BRTHG HIGH CONC OF VAP MAY CAUSE LT HEAD, GIDD,
SHORTNESS OF BRTH & MAY LEAD TO NARCOS, CARDIAC IRREGS,
UNCON/DEATH. MAY CAUSEEYE IRRIT. ISOBUTANE:HUMANS EXPOSED TO
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZS:HRS/DAY, 5 DAYS/WEEK FOR 4 WEEKS,
SHOWED NO CARDIAC PULM/OTHER FUNCTIONAL ABNORMS.
(ANIMAL STUDIES) HAS BEEN REPORTED TO BE REDUCED @ CONCS OF OVER
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INGEST:CALL MD IMMED . INHAL:REMOVE TO FRESH AIR, CALL MD. IF
NOT BRTHG, GIVE ARTF RESP. IF BRTHG IS DFCLT, GIVE OXYG. DO NOT
GIVE EPINEPHRINE/SIMILAR DRUGS. NOTES TO MD:BECAUSE OF POSS INCR
RIS K/ELICITING CARDIAC DYSRHYTHMIAS, CATECHOLAMINE DRUGS, SUCH AS
EPINEPHRINE, SHOULD BE CONSIDERED ONLY AS LAST RESORT IN LIFE
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:WATER SPRAY.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD PRESS DEMAND SCBA &
FULL PROT EQUIP . USE WATER SPRAY TO COOL CYLS TO PVNT
BURSTING/VENTING UNDER FIRE CNDTNS. PROD MAY BE (ING 4)
Unusual Fire/Explosion Hazard:CYLS MAY VENT OR RUPTURE IN FIRE
CONDITIONS, LEADING TO DECOMPOSITION. THERMAL DECOMPOSITION
PRODUCTS MAY INCLUDE FLUORIDES, CHLORIDES AND PHOSGENE .
* Accidental Release Measures *
Spill Release Procedures:USING NIOSH/MSHA APPRVD SELF-CNTND AIR SUPPLY
& FROSTBITE PROT, PERS SHOULD ATTEMPT TO CLOSE VALVE/REPAIR SOURCE
OF LEAK IF IT IS SFLY POSS TO DO SO. IF LG QTY IS RELS, EVACUATE
PERS, & ALLOW TO DISSI PATE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:NO SMOKING IN AREA OF USE. DO NOT USE IN GENERAL
VICINITY OF ARC WELDING, OPEN FLAMES OR HOT SURFACES. HEAT AND/OR
UV RADIATION MAY CAUSE THE FORMATION OF CHLORIDES, FLUORIDES OR
PHOSGENE .
* Physical/Chemical Properties *
Vapor Density:SUPP DATA
pH:NEUT
Solubility in Water:SLIGHT
Appearance and Odor:COLORLESS LIQUIFIED GAS WITH FAINT ETHERAL ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDANTS, INCLUDING OXYG. FRESHLY SCRAPED ALUMINUM, ALKALI
METALS, & ALKALI EARTH METALS (SODIUM, (SUPP DATA)
Stability Condition to Avoid:AVOID OPEN FLAMES AND HIGH TEMPERATURES.
FROM CONT W/HOT METALS, HEATING ELEMENTS, PILOT LIGHTS, INTERNAL
COMBUST (SUPDAT)
* Disposal Considerations *
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS .
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NOT REQUIRED UNDER NORMAL PRODUCT USAGE.
Ventilation:NOT REQUIRED UNDER NORMAL PRODUCT USAGE.
Other Protective Equipment:NOT REQUIRED UNDER NORMAL PRODUCT USAGE.
Supplemental Safety and Health
* Product Identification *
Preparer's Name:DALE M OREM
* Composition/Information on Ingredients *
Ingred Name:IODINE
Fraction by Wt: 1%
Other REC Limits:0.1 PPM
OSHA PEL:1 MG/CUM
ACGIH TLV:C 1.0 MG/CUM
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:IODINE-EYES: IRRITATION. SKIN: STAIN &
IRRITATION. INGESTION: BURNING SENSATION/ABDOMINAL PAIN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IODINE-EYES: IRRITATION. SKIN: STAIN &
IRRITATION. INGESTION: BURNING SENSATION & ABDOMINAL PAIN.
* First Aid Measures *
W/SOAP & WATER. INGESTION: GIVE 3 GLASSES OF WATER TO DRINK. OBTAIN
MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Extinguishing Media:WATERSPRAY.
Fire Fighting Procedures:PLASTIC COMPONENTS OF PRODUCT WILL BURN.
EXTINGUISHING MEDIA USED FOR FIRE FIGHTING WILL BE COMPATIBLE.
* Accidental Release Measures *
TOWELS. PICKUP ALL OTHER CONTAMINATED MATERIAL & PLACE IN BIOBAG.
AUTOCLAVE ALL MATERIAL BEFORE DISCARDING. DISINFECT THE EXPOSED
AREA ACCORDING TO PRECAUTI ONS AGAINTS MICROBIOLOGICAL HAZARDS.
*Handling and Storage *
Handling and Storage Precautions:OBSERVE PRECAUTIONS AGAINST
MICROBIOLOGICAL HAZARDS THROUGHOUT ALL PROCEDURES.
* Physical/Chemical Properties *
Appearance and Odor:PLASTIC DROPPERS W/LIGHT RED BROWN SOLUTION
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:AIR BRUSHING-USE NIOSH/MSHA CERTIFIED
RESPIRATOR. SANDING DRIED PAINT- USE NIOSH/MSHA CERTIFIED
RESPIRATOR. DUST & MIST- NIOSH/MSHA CERTIFIED MASK.
Ventilation:USE VENT AS REQUIRED TO CONTROL VAP CONC. USE WINDOW
EXHAUST FAN TO REMOVE VAPORS AND ASSURE ADEQUATE CROSS VENTILATION.
Other Protective Equipment:EYE WASH FOUNTAINS AND SAFETY SHOWERS SHOULD
BE AVAILABLE FOR USE IN AN EMERGENCY.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
* Product Identification *
CAGE:BINNE
CAGE:BINNE
* Composition/Information on Ingredients *
Ingred Name:NAPHTHOL RED LIGHT
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE:INERT, NUISANCE PARTICULATE DUST.
SKIN: NON-TOXIC. INHAL: INERT, NUISANCE PARTICULATE DUST.
INGEST:THIS PROD MAY BE IRRIT TO GI TRACT IF INGESTED. PRODUCT HAS
BEEN CERTIFIED AS NON-TOXIC BY THE AR T & CRAFT MATLS INSTITUTE &
ADVERSE HEALTH HAZARD.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:NO SPECIFIC HAZARD IS KNOWN.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN, EYE AND
RESPIRATORY DISORDERS, IMPAIRED FUNCTIONS FROM PRE-EXISTING
DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS PRODUCT.
* First Aid Measures *
ATTENTION IF ANY SYMPTOMS PERSIST. SKIN: WIPE EXCESS FROM SKIN AND
FLUSH WITH WATER USING SOAP IF AVAIL. SEEK MEDICAL ATTENTION IF
IRRITATIONOCCURS. INHAL: REMOVE TO FRESH AIR & TREAT
SYMPTOMATICALLY. INGEST: CONSULT MD, HOSPITAL, POISON CONTROL
CENTER.
* Fire Fighting Measures *
Extinguishing Media:USE WATER FOG, FOAM, DRY CHEMICAL OR CARBON
DIOXIDE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:PRODUCT AS SUPPLIED WILL SPLATTER AND
* Accidental Release Measures *
Spill Release Procedures:SOAK UP RESIDUE W/ABSORB SUCH AS CLAY/SAND/
OTHER SUITABLE MATL; PLACE IN NON-LEAKING CNTNRS FOR PROPER DISP.
FLUSH AREA W/H2O TO REMOVE TRACE RESIDUE;DISP AS NOTED. SML
SPILL:TAKE UP W/ ABSORB MATL & NON-LEAKING CNTNRS; SEAL TIGHTLY
FOR PROPER DISP
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:DO NOT INHALE SPRAY FROM AIR BRUSH. AVOID CONTACT
WITH EYES.
* Physical/Chemical Properties *
HCC:N1
Vapor Density:> 1
Spec Gravity:SUPP DATA
Evaporation Rate & Reference:< 1 (ETHER=1)
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:SUPDAT
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE KNOWN
Hazardous Decomposition Products:CO2, CO AND UNIDENTIFIED (UNKNOWN)
ORGANIC COMPOUNDS MAY BE FORMED.
* Disposal Considerations *
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH FEDERAL,
STATE AND LOCAL REGULATIONS . REFER TO LATEST EPA/STATE REGS
REGARDING PROPER DISPOSAL.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NORMALLY NOT NEEDED. USE SUPPLIED AIR
RESPIRATORY PROTECTION IN CONFINED OR ENCLOSED SPACES.
Ventilation:LOCAL EXHAUST-USE FOR CAPTURING FUMES/VAPORS.
AREAS.
Other Protective Equipment:CHEMICAL RESISTANT APRON OR OTHER CLOTHING
IF NEEDED. EYE WASH FOUNTAIN.
Work Hygienic Practices:WASH HANDS AND FACE AFTER USING. LAUNDER
CONTAMINATED CLOTHING BEFORE RE-USE.
Supplemental Safety and Health
NONE
* Product Identification *
Preparer's Name:SIGNATURE NOT CLEAR
* Composition/Information on Ingredients *
Ingred Name:NON HAZARDOUS INGREDIENT
Other REC Limits: RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PROLONGED OR REPEATED SKIN CONTACT MAY
CAUSE MILD IRRITATION. HEATED OIL MIST MAY BE IRRITATING TO
RESPIRATORY TRACT.
Explanation of Carcinogenicity: SPECIFIED BY MANUFACTURER.
Effects of Overexposure:REDNESS OR DRYING EFFECT ON SKIN.
Medical Cond Aggravated by Exposure:NO DATA AVALIABLE.
* First Aid Measures *
IRRITATION PERSISTS, GET MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point Method:COC
Lower Limits:N.D.
Upper Limits:N.D.
Extinguishing Media:FOAM, DRY CHEMICAL, CARBON DIOXIDE.
Fire Fighting Procedures:KEEP FIRE EXPOSED CONTAINERS COOL WITH WATER
SPRAY. WEAR PROTECTIVE CLOTHING. WATER OR FOAM MAY CAUSE FROTHING.
SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:CARBON DIOXIDE AND MONOXIDE.
* Accidental Release Measures *
Spill Release Procedures:RECOVER FREE LIQUID. ADD ABSORBENT TO SPILL
AREA. KEEP PETROLEUM PRODUCTS OUT OF DRAINS, SEWERS & WATERCOURSES
BY DIKING OR IMPOUNDING. ADVISE AUTHORITIES IF PRODUCT ENTERS OR
MAY ENTER SEWERS, WATERC OURSES OR EXTENSIVE LAND AREAS.
Neutralizing Agent:NOT APPLICABLE.
*Handling and Storage *
Handling and Storage Precautions:STORE IN COOL, DRY PLACE. KEEP AWAY
FROM STRONG OXIDANTS. KEEP CONTAINERS CLOSED WHEN NOT IN USE.
Other Precautions:AVOID BREATHING OIL-MIST. DISCARD OIL-SOAKED SHOES.
* Physical/Chemical Properties *
HCC:V6
Decomp Temp:Decomp Text:N.D.
Vapor Pres:N.D.
Vapor Density:N.D.
pH:N.D.
Evaporation Rate & Reference:N.D.
Solubility in Water:NEGLIGIBLE
Appearance and Odor:PALE YELLOW TO AMBER COLORED LIQUID, ESTER-LIKE
ODOR.
Percent Volatiles by Volume:N.D.
Corrosion Rate:N.D.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDANTS.
Stability Condition to Avoid: SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON MONOXIDE, SULFUR OXIDES.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL ENVIRONMENTAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF TLV IS EXCEEDED OR FOR SYMPTOMS OF OVER
EXPOSURE, WEAR NIOSH-APPROVED AIR-SUPPLIED RESPIRATOR. IN
EMERGENCY, WEAR A NIOSH-APPROVED POSITIVE-PRESSURE SELF-CONTAINED
BREATHING APPARATUS. WORK UNDER T HE HOOD.
Ventilation:MECHANICAL (GENERAL AND/OR LOCAL EXHAUST, EXPLOSION-PROOF)
VENTILATION TO MAINTAIN EXPOSURE BELOW TLV(S).
Other Protective Equipment:WEAR PROTECTIVE CLOTHING IN CASE OF REPEATED
OR PROLONGED CONTACT. PROVIDE EYE WASH & SAFETY SHOWER.
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. WASH AFTER HANDLING AND BEFORE EATING OR
DRINKING.
Supplemental Safety and Health
* Product Identification *
CAGE:0V1G7
CAGE:0V1G7
* Composition/Information on Ingredients *
Other REC Limits:NONE RECOMMENDED
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT RELEVANT
ACGIH TLV:NOT RELEVANT
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYES, SKIN, CNS,
RESPIRATORY & GI TRACTS. ACUTE- MAY CAUSE EYE, SKIN, RESPIRATORY
TRACT IRRITATION. INHALATION OR INGESTION MAY CAUSE CENTRAL NERVOUS
SYSTEM DEPRESSION. CHRONIC- UNKNOWN.
Explanation of Carcinogenicity:CONTAINS ETHYLENE DICHLORIDE.
Effects of Overexposure:IRRITATION, HEADACHE, DIZZINESS, NAUSEA,
VOMITING, DROWSINESS, FATIGUE, BLURRED VISION, DIARRHEA, CHEST
PAIN, COUGHING, COMA
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH PRE-EXISTING
DISEASES OF THE EYE, SKIN, RESPIRATORY TRACT, CNS MAY HAVE
INCREASED SUSCEPTIBILITY TO THE TOXICITY OF EXCESSIVE EXPOSURES.
* First Aid Measures *
First Aid:GET MEDICAL ATTENTION IF SYMPTOMS PERSIST. EYES:IMMEDIATELY
SOAP & WATER. INHALED:MOVE TO FRESH AIR. PROVIDE CPR/OXYGEN IF
NECESSARY.ORAL:CALL PHYSICIAN AT ONCE.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:6.2
Extinguishing Media:USE DRY CHEMICAL, CARBON DIOXIDE, FOAM. USE WATER
SPRAY TO COOL FIRE-EXPOSED CONTAINERS.
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS. HAZARDOUS DECOMPOSITION
PRODUCTS MAY BE FORMED.
Unusual Fire/Explosion Hazard:VERY FLAMMABLE. CONTAINERS MAY RUPTURE
DUE TO VAPOR PRESSURE BUILDUP.
* Accidental Release Measures *
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. ELIMINATE SOURCES
OF IGNITION. VENTILATE AREA. CONTAIN AND PICK UP SPILL WITH
NON-FLAMMABLE ABSORBENT SUCH AS SAND, EARTH, VERMICULITE. GROUND
ALL HANDLING EQUIPMENTS. PREVE NT LIQUID FROM ENTERING SEWERS OR
WATERWAYS.
Neutralizing Agent:NOT RELEVANT
*Handling and Storage *
Handling and Storage Precautions:STORE IN COOL, DRY, VENTILATED AREA,
AWAY FROM FLAMES, SPARKS & INCOMPATIBLES. CONTAINERS SHOULD BE
GROUNDED WHEN CONTENTS ARE BEING TRANSFERRED.
Other Precautions:"EMPTY" CONTAINERS RETAIN RESIDUE AND CAN BE
DANGEROUS. DO NOT WELD, SOLDER OR DRILL SUCH CONTAINERS. THEY MAY
EXPLODE AND CAUSE INJURY/DEATH. KEEP OUT OF REACH OF CHILDREN. DO
NOT INGEST. DO NOT GET IN EYES OR ON SKIN. DO NOT BREATHE VAPOR
* Physical/Chemical Properties *
HCC:F5
NRC/State Lic Num:NOT RELEVANT
Evaporation Rate & Reference:1.3 (N-BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:COLORLESS LIQUID - CHLOROFORM LIKE ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS, STRONG ALKALIES, ALUMINUM, LIQUID AMMONIA, METALLIC
FINES AND POWDERS
Stability Condition to Avoid:HEAT, SPARKS, FLAMES, OTHER IGNITION
SOURCES
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
OXIDES OF NITROGEN, PHOSGENE, HYDROCHLORIC ACID
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. RECOMMENDED PROCEDURE IS BY INCINERATION.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF PERSONAL EXPOS CANNOT BE CONTROLLED BELOW
APPLIC LIM BY VENT, WEAR NIOSH/MSHA APPRVD PROPERLY FITTED ORG
VAP/PARTICULATE RESP FOR PROTECTION AGAINST MATERIALS IN INGREDIENT
SECTION.
Ventilation:LOC EXHAUST PREF. GEN EXHAUST ACCEPTABLE IF EXPOS TO MATL
IS MAINTAINED BELOW APPLIC EXPOS LIM. REFER TO OSHA(SUPP DATA)
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRE FIGHT PROC: TO PREVENT PRESSURE BUILD-UP & POSSIBLE AUTOIGNITION
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:2,4-PENTANEDIOL, 2-METHYL-; (HEXYLENE GLYCOL)
Ingred Name:CARBON BLACK
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: IRRITATION OF EYES, SKIN AND
UPPER RESPIRATORY SYSTEM. IN CONFINED AREA VAPORS IN HIGH
CONCENTRATION MAY CAUSE HEADACHE, NAUSEA OR DIZZINESS.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:REDNESS AND ITCHING OR BURNING SENSATION MAY
INDICATE EYE OR EXCESSIVE SKIN EXPOSURE.
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.
* First Aid Measures *
First Aid:INHAL: REMOVE FROM EXPOSURE. RESTORE BREATHING. KEEP WARM AND
QUIET. SKIN: WASH AFFECTED AREA THOROUGHLY WITH SOAP AND WATER.
REMOVE CONTAMINATED CLOTHING AND LAUNDER BEFORE RE-USE. EYES: FLUSH
ATTENTION. INGEST: CALL MD .
* Fire Fighting Measures *
Flash Point Method:PMCC
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL AND FOAM.
Fire Fighting Procedures:NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP. H2O
SPRAY MAY BE INEFTIVE. IF H2O IS USED, FOG NOZ ARE PREF. H2O MAY BE
USED TO COOL CLSD CONTR (SUPP DATA)
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE (DUE TO
BUILD- UP OF PRESSURE) WHEN EXPOSED TO EXTREME HEAT.
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTR CLSD WHEN NOT IN USE.
TRANSFER ONLY IN APPRVD CONR W/COMPLETE & APPROP LABELING. DO NOT
TAKE INTERNALLY. KEEP OUT OF REACH CHILDREN.
Other Precautions:USE ONLY/W ADEQ VENT. AVOID BRTHG VAP/SPRAY MIST.
AVOID CONT W/SKIN/EYES.
* Physical/Chemical Properties *
HCC:N1
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:BY FIRE: CO*2, CO.
* Disposal Considerations *
Waste Disposal Methods:WASTE FROM PROD IS NOT HAZARDOUS AS DEFINED
INCINERATE IN APPROVED FACILITY. DO NOT INCINERATE CLOSED
CONTAINER. DISPOSE OF IN ACCORDANCE WITH FED, ST & LOC REGS
REGARDING POLLUTION.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH APPROVED DUST & MIST RESPIRATOR FOR
Ventilation:LOCAL EXHAUST: RECOMMENDED. MECHANICAL (GENERAL):
RECOMMENDED WHEN SPRAYING.
Other Protective Equipment:PROTECTIVE CLOTHING, SPRAY BOOTH IF IN THE
GLAZE FORM & APPLYING BY SPRAY
Work Hygienic Practices:WASH IMMEDIATELY AFTER HANDLING. CLEAN SPRAY
BOOTH FILTERS OFTEN.
Supplemental Safety and Health
FRITS ARE PRODUCED FROM THE CHEMICAL REACTIONS WHICH OCCUR DURING THE
HIGH TEMPERATURE SMELTING OF VARIOUS RAW MATERIALS TO FORM A MOLTEN
GLASS. THIS GLASS IS RAPIDLY COOLED & THEN GROUND TO PRODUCE P
OWDERED STRUCTURE OF THE FRIT. EXPOSURETO LEAD OCCURS IF IT
DISSOLVES OUT OF THE GLASS (WHICH OCCURS SLOWLY).
* Product Identification *
Preparer's Name:CURT SATHRE
* Composition/Information on Ingredients *
Ingred Name:SILICA DIOXIDE, CRYSTALLINE QUARTZ, SAND (SUSPECTED HUMAN
CARCINOGEN BY IARC & ACGIH)
Fraction by Wt: <9%
OSHA PEL:SEE TABLE Z3
Ingred Name:LEAD COMPOUNDS
Fraction by Wt: <4%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ABRASIVE, CAN SCRATCH EYES.
OVEREXPOSURE TO LEAD MAY CAUSE NERVOUS SYSTEM, KIDNEY, OR BONE
MARROW DAMAGE OR HARM TO THE DEVELOPING FETUS.
Explanation of Carcinogenicity:SEE INGREDIENTS.
Effects of Overexposure:LEAD TOXICITY: WEIGHT LOSS, STOMACH CRAMPS,
LOSS OF COORDINATION, JOINT & MUSCLE PAINS.
* First Aid Measures *
WATER. OBTAIN MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Fire Fighting Procedures:NONE. WILL NOT BURN.
* Accidental Release Measures *
Spill Release Procedures:CLEAN UP PROPERLY W/PAPER TOWELS & A WET
SPONGE.
*Handling and Storage *
Handling and Storage Precautions:WHEN USING, DON'T EAT, DRINK, OR
SMOKE. KEEP SEALED. KEEP OUT OF REACH OF CHILDREN. AVOID USING IF
PREGNANT OR CONTEMPLATING PREGNANCY.
Other Precautions:IF GLAZE SPRAYING, REGULAR BLOOD LEAD LEVEL TESTING
IS ADVISABLE.
* Physical/Chemical Properties *
Spec Gravity:1.5
Solubility in Water:INSOLUBLE
Appearance and Odor:COLORED LIQUID. ODORLESS.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
* Disposal Considerations *
Waste Disposal Methods:FOLLOW FEDERAL, STATE, & LOCAL REGULATIONS FOR
DISPOSAL.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH APPROVED DUST RESPIRATOR MUST BE WORN.
Ventilation:USE LOCAL EXHAUST AS NEEDED.
Other Protective Equipment:LOOSE FITTING CLOTHING COVERING ALL REQUIRED
AREAS.
Work Hygienic Practices:MFR:NIOSH DUST RESPIRATOR. HMIS:USE GOOD
INDUSTRIAL HYGIENE PRACTICE. WASH AFTER USING PRODUCT & BEFORE
EATING, DRINKING
Supplemental Safety and Health
KEY2:KT
* Product Identification *
Preparer's Name:RICHARD A. MOSS
* Composition/Information on Ingredients *
Ingred Name:BENTONITE
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 (DUST)
ACGIH TLV:5 MG/M3 (DUST)
Ingred Name:KAOLIN
Other REC Limits:NONE RECOMMENDED
Ingred Name:SILICA, AMORPHOUS, DIATOMACEOUS EARTH, CONTAINING LESS THAN
1% CRYSTALLINE SILICA
Other REC Limits:NONE RECOMMENDED
Ingred Name:MINERAL FIBERS
Other REC Limits:NONE RECOMMENDED
Ingred Name:PORTLAND CEMENT
Other REC Limits:NONE RECOMMENDED
Ingred Name:FLY ASH
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:IRRITATION TO EYES, SKIN OR
RESPIRATORY TRACT. CHRONIC:INHALATION CAN CAUSE SILICOSIS AND
POSSIBLY CANCER.
Explanation of Carcinogenicity:MINERAL FIBER IS POSSIBLE CAUSE (2B) OF
CANCER PER IARC.
Effects of Overexposure:IRRITATION TO EYES, SKIN OR RESPIRATORY TRACT.
Medical Cond Aggravated by Exposure:SPECIFIC IRRITATION TO EXPOSED
* First Aid Measures *
First Aid:FLUSH EYES WITH WATER, FLUSH SKIN WITH SOAP & WATER. DO NOT
RUB SKIN. CONSULT PHYSICIAN IF IRRITATION PERSISTS.
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:"N/A" HMIS:PRODUCT IS NON FLAMMABLE. EXTINGUISH
FIRE WITH MEDIA APPROPRIATE FOR SOURCE OF FIRE.
Fire Fighting Procedures:"N/A"HMIS:FIRE FIGHTERS SHOULD USE NIOSH
APPROVED SCBA & FULL PROTECTIVE EQUIPMENT WHEN FIGHTING FIRE.
* Accidental Release Measures *
Spill Release Procedures:SWEEP OR VACUUM.
Neutralizing Agent:NO INFORMATION GIVEN ON MSDS BY MFR.
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL DRY PLACE.
Other Precautions:NONE
* Physical/Chemical Properties *
HCC:N1
NRC/State Lic Num:NONE
Solubility in Water:TRACE
Appearance and Odor:LIGHT GREY - CEMENT OODR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
AVOID DIRECT CONTACT WITH STRONG ACIDS.
Stability Condition to Avoid:"STABLE"
Hazardous Decomposition Products:NONE
* Disposal Considerations *
Waste Disposal Methods:MFR:"CONVENTIONAL POWDER REMOVAL." HMIS:DISPOSE
I/A/W FEDERAL,STATE & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE REQUIRED IN NORMAL USE. IF REQUIRED, WEAR
NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN
.
Ventilation:NORMAL DILUTION GENERAL VENTILATION ADEQUATE FOR NORMAL
USE.
Other Protective Equipment:LAB COAT, SAFETY SHOWER AND EYE WASH.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
* Composition/Information on Ingredients *
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE SEVERE IRRITATION OF THE
EYES, SKIN AND MUCOUS MEMBRANES. MAY CAUSE GASTROINTESTINAL PAIN.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS
Medical Cond Aggravated by Exposure:
* First Aid Measures *
First Aid:SKIN:FLUSH WITH PLENTY OF WATER. EYES:FLUSH WITH WATER FOR AT
DILUTE. DO NOT INDUCE VOMITING. SEE MD IMMEDIATELY. INHAL:REMOVE TO
FRES H AIR. SUPPORT BREATHING (GIVE O2/ARTIFICIAL RESPIATION) .
* Fire Fighting Measures *
Flash Point:NOT FLAMMABLE
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NO ACUTE HAZARD. MOVE CONTAINER FROM FIRE
AREA IF POSSIBLE. AVOID BREATHING VAPORS OR DUST.
* Accidental Release Measures *
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED.
Other Precautions:
* Physical/Chemical Properties *
HCC:N1
Solubility in Water:MISCIBLE
Appearance and Odor:CLEAR LIQUID, NO ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, FLUORINE, ALUMINUM, ZINC, AND GALVANIZED STEEL.
Stability Condition to Avoid:NONE DOCUMENTED.
Hazardous Decomposition Products:NONE DOCUMENTED.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE AND LOCAL ENVIRONMENTAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH APPROVED RESPIRABLE FUME RESPIRATOR OR
AIR SUPPLIED RESPIRATOR WHEN WELDING IN CONFINED SPACE OR WHERE
LOCAL EXHAUST OR VENTILATION DOES NOT KEEP EXPOSURE BELOW TLV.
Ventilation:USE ENOUGH VENT, LOCAL EXHAUST AT ARC/BOTH, TO KEEP FUMES &
GASES BELOW TLV IN WORKER'S BREATHING ZONE & GENERAL AREA.
Other Protective Equipment:ANSI APPRVD EMER EYEWASH & DELUGE SHOWER .
WEAR HEAD, HAND & BODY PROT. CONT NEHC FOR MORE SPECIFIC INFO .
Work Hygienic Practices:TRAIN WELDER NOT TO TOUCH LIVE ELEC PARTS, TO
INSULATE HIMSELF FROM WORK & GROUND, & TO KEEP HIS HEAD OUT OF
FUMES.
Supplemental Safety and Health
APPEAR/ODOR: BONDED FLUXES ARE AGGLOMERATED MINERAL & ALLOY PARTICLES,
ODORLESS. EXPLO HAZ: SP, PUBLISHED BY AMERICAN WELDING SOCIETY,
FOR ADDNL FIRE PREVENTION & PROT INFO.
* Product Identification *
* Composition/Information on Ingredients *
Fraction by Wt: 3%
OSHA PEL:C 5 MG/M3 DUST
ACGIH TLV:5 MG/M3 DUST
Ingred Name:SILICA, CRYSTALLINE - QUARTZ; (SILICA)
OSHA PEL:SEE TABLE Z-3
ACGIH TLV:0.1 MG/M3 RDUST
Ingred Name:CALCIUM OXIDE
OSHA PEL:5 MG/M3
ACGIH TLV:2 MG/M3
Ingred Name:MAGNESIUM OXIDE
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
Ingred Name:SODIUM METASILICATE; (SILICATE BINDER)
OSHA PEL:5 MG/M3 (MFR)
Ingred Name:SILICATE BINDERS
OSHA PEL:5 MG/M3 (MFR)
Ingred Name:CRYOLITE (SODIUM ALUMINUM FLUORIDE); (SODIUM ALUMINUM
FLUORIDE)
OSHA PEL:2.5 MG/M3 (MFR)
ACGIH TLV:2.5 MG/M3 (MFR)
Ingred Name:HAZ DECOMP PROD: WORKED, PROCESS, PROC & CONSUMABLES USED.
ACTIVITIES). REASONABLY EXPECTED DECOMP PRODS INCL A COMPLEX OF
Ingred Name:EFTS OF OVEREXP: INGEST OF BARIUM OXIDE CAN RSLT IN SEV
Ingred Name:FIRST AID PROC: SEE MD . INGESTION: CALL MD IMMEDIATELY .
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ELEC ARC WORKING MAY CREATE ONE/MORE
OF THE FOLLOWING HLTH/PHYSICAL HAZS. FUMES & GASES CAN BE DANGEROUS
TO HLTH. ELEC SHOCK CAN KILL. ARC RAYS CAN INJURE EYES & BURN SKIN.
NOISE CAN DMG HEARING. ACUT E OVEREXP TO GASES, FUMES & DUSTS MAY
INCL IRRIT OF EYES, LUNGS, NOSE & THROAT. SOME TOX GASES ASSOC
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:CRYSTALLINE, SILICA-QUARTZ: IARC MONO,
TO BE CARCIN.
Effects of Overexposure:HLTH HAZ: W/WELDING MAY CAUSE PULM EDEMA,
ASPHY, & DEATH. ACUTE OVEREXP MAY INCL SIGNS & SYMPS SUCH AS WATERY
EYES, NOSE & THROAT IRRIT, HDCH, DIZZ, DFLCT BRTHG, FREQUENT
COUGH/CHEST PAIN. DUST GENERA TION FROM POURING/OTHERWISE HNDLG
Medical Cond Aggravated by Exposure:INDIVIDUALS W/ALLERGIES OR IMPAIRED
RESP FUNCTION MAY HAVE SYMPS WORSENED BY EXPOS TO WELDING FUMES.
HOWEVER, SUCH REACTION CANNOT BE PREDICTED DUE TO VARIATION IN
COMPOSITION & QTY OF DECOMP PRODS.
* First Aid Measures *
First Aid:IN CASE OF EMER, CALL FOR MED AID. EMPLOY FIRST AID TECHNIQUE
REC BY RED CROSS. INHAL: IF BRTHG IS DFCLT, GIVE OXYGEN & CALL FOR
MD. FOR ELEC SHOCK, DISCONNECT & TURN OFF POWER. IF NOT BRTHG,
BEGIN AR TF RESP, PREF MOUTH-TO-MOUTH. IF NO DETECTABLE PULSE,
BEGIN CPR. IMMED CALL MD. SKIN: FOR ARC BURN, APPLY COLD, CLEAN
* Fire Fighting Measures *
Extinguishing Media:ONLY PACKAGING FOR THIS PROD WILL BURN. USE
EXTINGUISHING MEDIA RECOMMENDED FOR BURNING MATERIALS & FIRE
SITUATION.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:THIS PROD WILL NOT BURN. HOWEVER, WELDING
IN WELDING & CUTTING" & "SAFE PRACT" CODE: (SUP DAT)
* Accidental Release Measures *
Spill Release Procedures:NOT APPLICABLE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:READ AND UNDERSTAND THE MANUFACTURER'S
INSTRUCTIONS AND THE PRECAUTIONARY LABEL ON THIS PRODUCT.
* Physical/Chemical Properties *
Appearance and Odor:FUSED FLUXES ARE GRANULATED GLASS-LIKE PARTICLES,
ODORLESS. (SUP DAT)
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE CURRENTLY KNOWN.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:WELDING FUMES & GASES CANNOT BE
CLASSIFIED SIMPLY. COMPOSITION & QTY OF BOTH ARE DEPENDENT UPON
* Disposal Considerations *
Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT, RESIDUE, DISPOSABLE CONTAINER, OR
LINER IN AN ENVIRONMENTALLY ACCEPTABLE MANNER, IN FULL COMPLIANCE
WITH FEDERAL, STATE A ND LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE IN WELL VENTILATED AREA. USE NIOSH/MSHA
APPROVED RESPIRATORY PROTECTION IF TLV EXCEEDED OR OVER EXPOSURE IS
LIKELY.
Ventilation:MECHANICAL VENTILATION.
Other Protective Equipment:RUBBER APRON. EYEWASH STATIONS.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
HNDLG/STOR PREC:WHERE APPROPRIATE VENTILATION SYSTEMS EXIST. KEEP
AWAY F ROM FOOD & SMOKING MATERIALS. WASH HANDS BEFORE EATING &
SMOKING. UNCURED PROD CONT IRRITATES EYES. AVOID CONT W/EYES.
* Product Identification *
Preparer's Name:A L DRAKE
* Composition/Information on Ingredients *
Ingred Name:1,2-BENZENEDICARBOXYLIC ACID, D1-2-PROPENYL ESTER;
Ingred Name:NON HAZARDOUS INGREDIENTS
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INGEST: HARMFUL IF SWALLOWED.
INHAL: MAY CAUSE MILD RESPIRATORY IRRITATION. SKIN: CAUSES MODERATE
SKIN IRRITATION. EYE: CAUSES MILD EYE IRRITATION. CAUSES CORNEAL
BURNS. CHRONIC: RESPIRATORY AI LMENTS. LIVER AND KIDNEY DAMAGE.
CUMULATIVE SYSTEMATIC TOXICITY. EYE DAMAGE. CAN BE ABSORBED THROUGH
SKIN.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:LIVER, KIDNEY BLOOD DISORDERS.
* First Aid Measures *
First Aid:INGEST:INDUCE VOMIT IMMED BY GIVING 2 GLASSES OF H2O &
STICKING FINGERS DOWN THROAT; NEVER GIVE ANYTHING TO AN UNCON
PERSON. GET MED ATTN. SKIN:REMOVE CONTAMD CLTHG & LAUNDER BEFORE
REUSE. WASH W/SOAP /H2O. GET MED ATTN IF IRRIT PERSISTS.
INHAL:REMOVE TO FRESH AIR, IF NOT BRTHG GIVE ARTF RESP, PREFERABLY
MOUTH-TO-MOUTH. IF BRTHG IS DFCLT GIVE O2. GET MED ATTN. EYES:IMMED
FLUSH W/PLENTY(SUPDAT)
* Fire Fighting Measures *
Flash Point Method:PMCC
Extinguishing Media:ALCOHOL FOAM; CARBON DIOXIDE; DRY CHEMICAL; WATER
MIST.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . EVACUATE AREA AND FIGHT FIRE FROM SAFE
DISTANCE.
Unusual Fire/Explosion Hazard:POLYMERIZATION MAY TAKE PLACE DURING FIRE
DUE TO ELEVATED TEMPERATURES. CLOSED CONTAINERS MAY VIOLENTLY
RUPTURE.
* Accidental Release Measures *
Spill Release Procedures:WIPE, SCRAPE OR SOAK UP IN AN INERT MATERIAL
AND PUT IN A CONTAINER FOR DISPOSAL. REMOVE SOURCES OF IGNITION.
WARN OTHER WORKERS OF SPILL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTR CLSD WHEN NOT IN USE TO
PVNT CONT W/ACIDIC/BASIC/OXDIZING MATL. DURING CURE, VAP ARE GIVEN
OFF WHICH MAY BE HARMFUL. CURE ONLY (SUPP DATA)
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
* Physical/Chemical Properties *
HCC:N1
Evaporation Rate & Reference:>1(BUTYL ACETATE=1)
Solubility in Water:SLIGHT
Appearance and Odor:AMBER LIQUID, MILD PLEASANT ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH ACIDIC, BASIC OR OXIDIZING AGENTS. METAL SALTS SUCH
AS ALUMINUM CHLORIDE.
Stability Condition to Avoid:KEEP AWAY FROM HEAT, SPARKS, FLAME.
Hazardous Decomposition Products:CARBON MONOXIDE. CARBON DIOXIDE. FUMES
OF ALLYIC COMPOUNDS.
* Disposal Considerations *
Waste Disposal Methods:DISPOSAL SHOULD BE MADE IN ACCORDANCE WITH
FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPROVED FUME RESPIRATOR OR AN
AIR SUPPLIED RESPIRATOR WHERE LOCAL EXHAUST/VENTILATION DOES NOT
KEEP EXPOSURE BELOW OSHA PEL.
Ventilation:LOCAL EXHAUST VENTILATION SHOULD BE USED TO CNTRL EXPOS TO
AIRBORNE DUST/FUME WHENEVER POSSIBLE.
Other Protective Equipment:PROTECTIVE CLOTHING SUCH AS UNIFORMS,
DISPOSABLE COVERALLS, SAFETY SHOES, ETC.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EFTS OF OVEREXP:TO PERM DISABILITY DUE TO LOSS OF LUNG FUNCTION,
FIBROSIS OR SUBSEQUENT EFTS ON HEART. CNS DEPRESS HAS BEEN
IDENTIFIED W/EXCESSIVE MANGANESE EXPOS. NICKEL/CHROMIUM METAL HAVE
BEEN LINK ED TO RESP TRACT CANCERS. ALUMINUM AND IRON HAVE BEEN
INDICATED TO CAUSE GI DISORDERS. EYE PROT:WITH TINTED LENS .
* Product Identification *
Preparer's Name:SAFETY DEPARTMENT
* Composition/Information on Ingredients *
Ingred Name:FIRST AID PROC:GET MD. CONTACT LENSES SHOULD NOT BE WORN IF
WORKING WITH METAL DUSTS AND POWDERS.
Ingred Name:SPILL PROC:ENVIRON PROBLEMS.METAL POWDERS/DUSTS MAY HAVE
Other REC Limits:NONE SPECIFIED
Ingred Name:ING 9:SPILLS & RELEASES TO ENVIRON (DISCHARGE TO STREAMS,
Ingred Name:CHROMIUM (SARA III)
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:COPPER (SARA III)
Fraction by Wt: 1.8%
OSHA PEL:0.1MG/M3 FUME
ACGIH TLV:0.2MG/M3 FUME
Ingred Name:IRON (III) OXIDE;(IRON)
Ingred Name:MANGANESE (SARA III)
Fraction by Wt: 1.0%
OSHA PEL:(C) 5 MG/M3 DUST
Ingred Name:MOLYBDENUM
Fraction by Wt: 3.1%
Ingred Name:NICKEL (SARA III)
Fraction by Wt: 9%
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3
Ingred Name:SILICON
Fraction by Wt: 0.5%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:UNDER NORMAL HANDLING & USE OF SOLID
FORM OF THESE MATLS THERE ARE FEW HEALTH HAZS. CUTTING, WELDING,
MELTING, GRINDING, ETC. OF THESE MATLS WILL PRODUCE DUST/FUME OR
PARTICULATE WHICH MAY PRESENT SIG NIF HLTH HAZS. ACUTE:METAL
DUST/FUMES OF THOSE ELEMENTS IN ING SECTION CAN CAUSE IRRIT TO
SKIN, EYES (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NICKEL:GROUP 2B (IARC); ANTICIPATED TO
BE A CARCINOGEN (NTP).
Effects of Overexposure:HLTH HAZ:& MUC MEMBS, ALLERGIC SKIN RXNS/ DERM.
INJURY TO EYES IS GENERALLY RSLT OF PARTICULATE IRRIT OR MECH
INJURY TO CORNEA OR CONJUNCTIVA BY DUST. EXCESS INHAL CAN CAUSE
RESP IRRIT, COUGH, BRONCH,CHILLS, "FUME FEVER" & ASTHMA-LIKE
SYMPS. CHRONIC:RESP DISEASE W/ SYMPS RANGING FROM SHORTNESS OF
BREATH & COUGH (SUPDA
Medical Cond Aggravated by Exposure:SKIN SENSITIVITY, PULMONARY
DISEASES, NEUROLOGICAL DAMAGE/DISEASE, AND CIRCULATORY, BLOOD, &
KIDNEY DISEASE.
* First Aid Measures *
First Aid:INHAL:IF BRTHG DFCLT, REMOVE TO FRESH AIR. IF BRTHG STOPPED,
GIVE ARTF RESP & GET MD IMMED. INGEST:IF LRG AMTS OF DUST INGESTED,
SWALLOW LRG QTYS OF WATER & ATTEMPT TO INDUCE VOMIT IF CONSCIOUS.
GET M D IMMED. SKIN:TREAT SKIN CUTS/ABRASIONSBY STANDARD FIRST AID.
REMOVE DUST BY WASHING W/SOAP & WATER. IF IRRIT PERSISTS, GET MD.
8)
* Fire Fighting Measures *
Flash Point:NONE
Lower Limits:NONE
Upper Limits:NONE
Extinguishing Media:THESE ALLOYS ARE NONCOMBUSTIBLE. USE EXTINGUISHING
MEDIA APPROPRIATE TO THE SURROUNDING FIRE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. TO EXTINGUISH METAL POWDER FIRE USE DRY SAND, DRY GRAPHITE OR
OTHER CLASS "D" FIRE EXTINGUISHING POWDER.
Unusual Fire/Explosion Hazard:NO UNUSUAL OR EXPLOSION HAZARDS ARE
ASSOCIATED WITH THESE MATERIALS.
* Accidental Release Measures *
Spill Release Procedures:SOLID FORM:NO SPECIAL CLEAN-UP PROBLEMS. DUST
FORM:USE VACUUM SYS UTILIZING HEPA FILTRATION SYS. MIN AIRBORNE GEN
OF DUST/AVOID CONTAM OF AIR & WATER. PROPERLY LABEL ALL MATLS
COLLECTED IN WASTE CNTNR .IN SOLID FORM THESE MATLS POSE NO
SPECIAL(ING 9)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:THESE PRODUCTS MUST BE HANDLED
ACCORDING TO SIZE, SHAPE AND QUANTITY OF MATERIALS INVOLVED.
Other Precautions:SOLID METAL MAY REQUIRE USE OF HOISTS, CRANES, ETC.
POWDERS SHOULD BE MOVED OR TRANSPORTED TO MINIMIZE SPILL OR RELEASE
POTENTIAL.
* Physical/Chemical Properties *
HCC:N1
Solubility in Water:NONE
Appearance and Odor:SOLID-SILVER GRAY COLOR-NO ODOR
Percent Volatiles by Volume:NONE
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
AVOID CNTCT W/MINERAL ACIDS & OXIDIZING AGENTS WHICH MAY GENERATE
HYDROGEN GAS; EVOLUTION OF HYDROGEN MAY BE EXPLO HAZ.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:ELEMENTAL METALS & METAL OXIDES FROM
WELDING, CUTTING, GRINDING, MELTING OR DROSS OPERATIONS.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF WASTE MATERIAL IN ACCORDANCE WITH
LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
SELF-CONTAINED BREATHING APPARATUS.
Ventilation:USE GENERAL DILUTION VENTILATION.
Other Protective Equipment:APRON AND WORK CLOTHING TO MINIMIZE
EXPOSURE. EYE WASH STATION & SAFETY SHOWER RECOMMENDED.
Work Hygienic Practices:WASH THOROUGHLY AFTER USE AND BEFORE EATING,
SMOKING OR USING TOILET FACILITIES. DO NOT BREATH VAPORS OR MIST.
Supplemental Safety and Health
NONE
* Product Identification *
Product ID:CLEANING COMPOUND,SOLVENT,TRICHLOROTRIFLUOROETHANE-AEROSOL
CAGE:0ATV9
CAGE:0ATV9
* Composition/Information on Ingredients *
III)
Other REC Limits: RECOMMENDED
Ozone Depleting Chemical:1
Ingred Name:CARBON DIOXIDE
Fraction by Wt: 5%
Other REC Limits: RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES:PERSONS WEARING CONTACT LENSES
SHOULD USE SAFETY GLASSES.MAY CAUSE IRRITATION.SKIN:MAY CAUSE
IRRITATION AND DEFATTING.INGEST:MAY CAUSE GI TRACT
IRRITATION.INHAL:MAY CAUSE RESPIRATORY IRRITATION A ND CNS
DEPRESSION.CHRONIC:MAY DAMAGE LIVER,IRREGULAR HEARTBEAT.
Explanation of Carcinogenicity:THERE ARE NO INGREDIENTS ABOVE 0.1%
WHICH ARE IDENTIFIED AS CARCINOGENS BY NTP,IARC OR OSHA.
Effects of Overexposure:INHAL:DIZZINESS,DROWSINESS,HEAVY
FEELING.FLUSHING,HEADACHE,DIZZINESS,NAUSEA.HIGH CONCENTRATION MAY
CAUSE HEART
ARRYTHMIA.INGEST:DISCOMFORT.SKIN:DERMATITIS.EYES:CONJUNCTIVITIS.
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING HEART
ARRYTHMIAS,LIVER,RETINA,GI,REPRODUCTIVE OR CENTRAL NERVIOUS SYSTEM
AILMENTS MAY BE AT INCREASED RISK FROM EXPOSURE.
* First Aid Measures *
First Aid:SKIN:REMOVE CONTAMINATED CLOTHING;WASH WITH
WATER.EYES:PERSONS WEARING CONTACTS SHOULD BE USING SAFETY
AIR.DO NOT GIVE EPINEPHRINE.GIVE OX YGEN OR ARTIFICIAL RESPIRATION
IF NEEDED.INGEST:GET PROMPT QUALIFIED MEDICAL ATTENTION.IF
CONSCIOUS,GIVE 2-4 GLASSES OF WATER AND INDUCE VOMITING WITH
CONSENT OF DOCTOR BY STICKING FINGER DOWN THROAT.
* Fire Fighting Measures *
Flash Point:
Extinguishing Media:THIS ITEM IS NON-FLAMMABLE.USE MEDIA APPROPRIATE
FOR SURROUNDING FIRE.
Fire Fighting Procedures:USE A SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE EQUIPMENT.COOL FIRE EXPOSED CONTAINERS WITH WATER
FOG.
Unusual Fire/Explosion Hazard:CONTAINERS MAY BURST FROM HEAT OF
IRE.COMBUSTION OR HEAT OF FIRE MAY PRODUCE HAZARDOUS DECOMPOSITION
PRODUCTS AND VAPORS.
* Accidental Release Measures *
Spill Release Procedures:VENTILATE AREA.EVACUATE PERSONNEL.SOAK UP WITH
NON-COMBUSTIBLE INERT ADSORBANT(EG.CLAY);PLACE COLLECTED MATERIEL
IN AN APPROPRIATE CONTAINER FOR DISPOSAL.USE SPARK-PROOF EQUIPMENT.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL, DRY, WELL-VENTILATED
LOCATION, AWAY FROM ANY AREA WHERE THE FIRE HAZARD MAY BE ACUTE.
KEEP CONTAINERS CLOSED WHEN NOT IN USE.
Other Precautions:AVOID BREATHING FUMES.BE CAUTIOUS OF VAPOR BUILDUP IN
LOW AREAS.THE DECOMPOSITION PRODUCTS FROM THIS MATERIAL ARE QUITE
TOXIC.
* Physical/Chemical Properties *
HCC:V2
Vapor Density:6.5
Evaporation Rate & Reference:2 ETHER=1
Appearance and Odor:AEROSOL.LIQUID IS CLEAR,COLORLESS WITH SLIGHT
ETHEREAL ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG ALKALIDES,OXIDIZERS,ALUMINUM,HOT REACTIVE METALS.
Stability Condition to Avoid:HIGH HEAT;MATERIAL WILL DECOMPOSE ABOVE
Hazardous Decomposition Products:HALOGENS AND HALOGEN ACIDS,POSSIBLY
PHOSGENE,CARBON MONOXIDE,CARBON DIOXIDE,OXIDES OF NITROGEN.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL,STATE AND
LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED CONTAINED TYPE RESPIRATOR.
Ventilation:AS MUCH AS POSSIBLE - LOCAL & MECHANICAL (SPARK PROOF).
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:WASH THOROUGHLY AFTER USE. IF NO SKIN CLEAN
IMMEDIATELY W/VASELINE OR BABY OIL.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:HEXANE (CERCLA)
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:MAGNESIUM OXIDE
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:DRY THROAT, NAUSEA, DRY SKIN,
DIFFICULTY BREATHING. NOTE:TOLUENE APPEARS ON THE NAVY LISTING OF
OCCUPATIONAL CHEMICAL REPRODUCTIVE HAZARDS. SEEK CONSULTATION FROM
APPROPRIATE HEALTH PROFESSIONALS CONC ERNING LATEST HAZARD LIST
INFORMATION &SAFE HANDLING & EXPOSURE INFORMATION .
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:ANY DIFFICULTY IN BREATHING.
* First Aid Measures *
First Aid:INGEST:CALL MD IMMEDIATELY . INHAL:REMOVE FROM AREA TO OPEN
AREA W/PLENTY OF VENTILATION - LIE DOWN, KEEP QUIET. CALL MD.
SKIN:WASH AFFECTED AREA IMMEDIATELY W/SOAP & WATER - CLEAN W/BABY
MINUTES & CALL MD IMMEDIATELY.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:1%
Upper Limits:7%
Extinguishing Media:CARBON DIOXIDE OR DRY CHEMICAL EXTINGUISHER.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . AIM AT BASE OF FIRE.
Unusual Fire/Explosion Hazard:
* Accidental Release Measures *
Spill Release Procedures:CLEAN UP W/NON-FLAMMABLE SOLVENT - KEEP
CONTAINED AS MUCH AS POSSIBLE - USE ABSORBANT TO SOAK UP AS MUCH AS
POSSIBLE.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:DO NOT SMOKE WHEN USING - STORE IN
DRY, COOL AREA AWAY FROM FIRE & FLAME. KEEP AWAY FROM FIRE & FLAME
- USE CAUTION UNTIL VAPORS HAVE CLEARED.
Other Precautions:AVOID OVEREXPOSURE TO VAPORS. REMOVE BUNGS SLOWLY
FROM DRUMS - AVOID OVEREXPOSURE TO VAPORS.
* Physical/Chemical Properties *
Evaporation Rate & Reference:2.7 (MIN)
Solubility in Water:NONE
Appearance and Odor:LIGHT TO TAN COLOR; SOLVENT ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:
* Disposal Considerations *
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS . ALLOW TO DRY & SOLVENTS TO EVAPORATE - (CRUSH EMPTY
CONTAINERS) 1ST - TRIPLE RINSE & KEEP BUNGS TIGHTLY SEALED UNTIL
DISPOSED OF. DISP OSE OF IN APPROVED LANDFILL.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR MUST BE WHEN
VAPOR OR MIST CONCENTRATIONS EXCEED TLV.
Ventilation:MECHANICAL (GENERAL): NORMALLY SUFFICIENT
Other Protective Equipment:SAFETY SHOWER/EYE WASH FOUNTAINS SHOULD BE
PROVIDED. IMPERVIOUS BOOTS, APRONS ARE RECOMMENDED IF SKIN CONTACT
IS LIKELY.
Work Hygienic Practices:AVOID BREATHING SPRAY MIST.
Supplemental Safety and Health
* Product Identification *
Product ID:RUST & SCALE SOLVENT
* Composition/Information on Ingredients *
Ingred Name:PHOSPHORIC ACID (SARA III)
Other REC Limits:1 MG/CUM
OSHA PEL:1 MG/M3/3 STEL
Ingred Name:2-BUTOXYETHANOL
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN CONTACT MAY CAUSE IRRITATION OR
BURNS. 2-BUTOXYETHANOL MAY ABSORBED IN HARMFUL AMOUNTS. EYE BURNS
EXPECTED UPON DIRECT CONTACT. BREATHING OF MIST & VAPORS MAY CAUSE
RESPIRATORY IRRITATION. INGEST ION MAY CAUSE SEVERE INTERNAL
IRRITATION. CHRONIC EXPOSURE MAY CAUSE BLOOD EFFECTS, AND LIVER OR
KIDNEY INJURY.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:PROLONGED SKIN CONTACT MAY CAUSE REDNESS,
BURNING. DIRECT EYE CONTACT CAUSES BURNS. ACUTE OVEREXPOSURE TO
2-BUTOXYETHANOL MAY CAUSE LETHARGY, DROWSINESS, & IRRITATION TO
EYES & MUCOUS MEMBRANES.
* First Aid Measures *
WATER. REMOVE CONTAMINATED CLOTHING & LAUNDER BEFORE REUSE.
INGESTION: IF CONSCIOUS, GIVE LARGE AMOUNTS OF WATER. DON'T INDUCE
VOMITING. CALL PHYSICIAN. INHALATION: REMOVE TO FRESH AIR.
ADMINISTER OXYGEN IF BREATHING IS DIFFICULT. GET MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point Method:PMCC
Extinguishing Media:WATER, CO2, DRY CHEMICAL
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:PROLONGED CONTACT OF PHOSPHORIC ACID WITH
METALS MAY LIBERATE HYDROGEN, A FLAMMABLE GAS.
* Accidental Release Measures *
Spill Release Procedures:SMALL SPILLS-NEUTRALIZE THE SPILL AREA W/SODA
A<SH & FLUSH TO SANITARY SEWER WITH PLENTY OF WATER. LARGE
SPILLS-CONTAIN SPILL. DIKE TO PREVENT SPREADING. PUMP TO SALVAGE
TANK, NEUTRALIZE RESIDUES WITH SODA ASH/FLUSH WITH WATER.
Neutralizing Agent:SODA ASH
*Handling and Storage *
Handling and Storage Precautions:THIS PRODUCT IS CORROSIVE TO MOST
METALS. STORE & HANDLE ONLY IN CONTAINERS MADE OF POLYETHYLENE.
STORE IN A COOL, DRY, WELL VENTILATED AREA.
* Physical/Chemical Properties *
Evaporation Rate & Reference:(WATER = 1): 1.0
Solubility in Water:COMPLETE
Appearance and Odor:LIGHT AMBER LIQUID, ETHEREAL ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG CAUSTICS
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:CO, CO2, PHOSPHORIC OXIDE
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE TO FEDERAL, STATE &
LOCAL LAWS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:RESPIRATORY PROTECTION IS RECOMMENDED BUT ONLY
REQUIRED IF TLV'S ARE EXCEEDED. USE A NIOSH/MSHA APPROVED
SUBPART(1) OF OSHA'S LEAD S TANDARD.
Ventilation:IF FUME OR DUST IS BEING GENERATED, MECHANICAL VENTILATION
MUST BE PROVIDED TO MAINTAIN EXPOSURE LEVELS BELOW TLV'S.
Other Protective Equipment:SKIN PROTECTION: NOT NORMALLY NEEDED.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:TIN
Other REC Limits:2 MG/M3 (OSHA ORG)
OSHA PEL:2 MG/M3 (INORGANIC)
ACGIH TLV:2 MG/M3
Ingred Name:LEAD
ACGIH TLV:0.5 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:ROSIN
Minumum % Wt:0.
Maxumum % Wt:3.
Ingred Name:TRADE SECRET. (CAS N/A)
< Wt:.6
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: DUST OR FUME COULD BE IRRITANT TO
EYES NOSE/THROAT. SKIN: NOT A ROUTE OF ENTRY. SKIN ABSORPTION: NOT
A ROUTE OF ENTRY. INGESTION: INGESTION OF DUST OR FUME MUST BE
AVOIDED. LEAD IS TOXIC AND CUMU LATIVE, AFFECTING KIDNEYS,
REPRODUCTIVE SYSTEM AND NERVOUS SYSTEM. SYMPTOMS OF CHRONIC
OVEREXPOSURE INCLUDE ANEMIA, INSOMNIA, WEAKNESS, IRRITABILITY,
CONSTIPATION AND STOMACH PAINS. TIN IS NOT TOXIC B UT EXCESSIVE
EXPOSURE CAN CAUSE FEVER, NAUSEA, STOMACH CRAMPS OR DIARRHEA.
INHALATION: INHALATION OF DUST AND FUMES MUST BE AVOIDED.
IRRITATION OF NOSE/BRONCHIAL TRACTS OCCUR, EFFECTS FROM ABSORPTION
OF LEAD, ETC IN BLOOD STREAM.
Explanation of Carcinogenicity:INGREDIENTS IN MSDS ARE EACH MARKED AS
NOT A CARCINOGEN.
Effects of Overexposure:EYES: IRRITATION OF EYES, NOSE, THROAT.
INGESTION: LEAD IS TOXIC AND CUMULATIVE, AFFECTING KIDNEYS,
REPRODUCTIVE SYSTEM, AND NERVOUS SYSTEM. SYMPTOMS OF CHRONIC
OVEREXPOSURE INCLUDE ANEMIA, INSOMNIA, WEAKNESS, IRRITABILITY,
CONSTIPATION, AND STOMACH PAINS. TIN IS NOT REGARDED AS TOXIC BUT
EXCESSIVE EXPOSURE CAN CAUSE FEVER, NAUSEA, STOMACH CRAMPS OR
DIARRHEA. INHALATION: IRRITATION OF NOSE/BRONCH IAL TRACTS, EFFECTS
FROM ABSORPTION OF LEAD, ETC IN BLOOD STREAM.
* First Aid Measures *
WITH SOAP AND WATER. REMOVE CONTAMINATED CLOTHING. INGESTION:
INDUCE VOMITING IF PERSON IS CONSCIOUS. GET MEDICAL ATTENTION.
INHALATION: RE MOVE TO FRESH AIR. GET MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point Method:CC
FLUX ONLY
Fire Fighting Procedures:IF METAL IS PRESENT WHERE THERE IS A FIRE,
WEAR SELF-CONTAINED BREATHING APPARATUS IN CASE OF POISONOUS LEAD
FUMES.
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
Spill Release Procedures:ALLOW TO SOLIDIFY AND COLLECT IN SEALED DRUMS
FOR DISPOSAL.
*Handling and Storage *
Handling and Storage Precautions:STORAGE: STORE IN DRY CONDITIONS.
THESE PRODUCTS ARE HANDLED. PERSONNEL MUSTWASH THOROUGHLY AFTER
HANDLING THE METAL BEFORE DRINKING, EATING OR SMOKING.
* Physical/Chemical Properties *
HCC:N1
M.P/F.P Text:MELTING PT (APPROX)
Vapor Pres:NOT VOLATILE
Vapor Density:NOT VOL
Solubility in Water:NIL
Appearance and Odor:SILVER/GRAY COLORED METAL WIRE. ODOR: SLIGHT.
Percent Volatiles by Volume:0-4 WT
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, OXIDIZERS, REDUCING AGENTS.
Hazardous Decomposition Products:LEAD FUMES AT HIGH TEMPERATURES (ABOVE
Conditions to Avoid Polymerization:WILL NOT OCCUR.
* Disposal Considerations *
Waste Disposal Methods:ALLOW TO SOLIDIFY AND COLLECT IN SEALED DRUMS
FOR DISPOSAL.
* MSDS Transport Information *
Transport Information:PROPER SHIPPING NAME: NOT REQUIRED. UN NUMBER:
N/A. NA NUMBER: N/A. DOT EXEMPTION NO: N/A. HAZARD CLASSES:
N/A.
* Regulatory Information *
SARA Title III Information:THIS PRODUCT CONTAINS A CHEMICAL SUBJECT TO
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:SUPPLIED AIR W/FULL FACEPIECE,HELMET OR HOOD
Ventilation:LOCAL EXHAUST
Other Protective Equipment:FULL CLOTHING TO PREVENT SKIN CONTACT
Supplemental Safety and Health
OVEREXPOS:CAN CAUSE FORMATION OF CYSTS,CAUSES STILLBIRTHS.IRRITATES
EYES,NOSE THROAT.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:POLYCHLORINATED BIPHENYLS (PCBS) (SARA III)
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
* Hazards Identification *
Effects of Overexposure:ABSORBED THRU SKIN,LUNGS,INTESTINE.CAUSES
CANCER,LIVER,KIDNEY,STOMACH,EYE,HEARING DISORDER(SUP DATA)
* First Aid Measures *
First Aid:EYES:FLUSH W/WATER IMMEDIATELY.SKIN:WASH W/SOAP
IMMEDIATELY.INHAL:REMOVE TO FRESH AIR,GIVE ART.RESPIR.AS
NEEDED.INGEST:GET MEDICAL ATTN.GIVE LARGE QTY OF SALT WATER,INDUCE
VOMITING,BUT DO NOT MAKE UNC ONSCIOUS PERSON VOMIT.
* Accidental Release Measures *
Spill Release Procedures:USE ABSORBENT & DIKES TO PREVENT
RUNOFF.ISOLATE & NOTIFY PROPER AUTHORITIES.
*Handling and Storage *
Handling and Storage Precautions:STORAGE MUST FOLLOW RCRA REQUIREMENTS.
* Physical/Chemical Properties *
Appearance and Odor:LIGHT STRAW-COLORED LIQUID,AROMATIC ODOR
* Stability and Reactivity Data *
STRONG OXIDIZERS
* Disposal Considerations *
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-GENERALLY HIGH
TEMPERATURE INCINERATION.ONLY APPROVED DISPOSAL OPERATOR PERMITTED.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE IN WELL VENTILATED AREAS ONLY. WEAR
NIOSH/MSHA APPRVD TYPE C AIR SUPPLIED RESPIRATOR IF VENT IS INADEQ
TO KEEP SOLVENT INHAL VAPORS BELOW TLV.
Ventilation:AVOID AIRBORNE MISTS WHICH CAN BE INHALED/SWALLOWED. USE
PROTECTIVE MASK, IF NECESSARY.
Other Protective Equipment:ANSI APPRVD EMERGENCY EYE WASH & DELUGE
SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
* Product Identification *
CAGE:CIMIN
CAGE:CIMIN
* Composition/Information on Ingredients *
Ingred Name:ASPHALT (PETROLEUM)
OSHA PEL:N/K
ACGIH TLV:5 MG/M3; (FUME)
Ingred Name:AMINE COMPOUNDS
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:STODDARD SOLVENT
Ingred Name:SOLVENT NAPHTHA (PETROLEUM), LIGHT AROMATIC; (AROMATIC
PETROLEUM DISTILLATES)
Fraction by Wt: 2%
Ingred Name:EFTS OF OVEREXP:EXPOS TO PETRO ASPHALT & CANCER IN HUMANS.
IARC HAS DETERM THERE IS LIMITED EVID OF CARCIN FOR (ING 6)
Ingred Name:ING 5:UNDILUTED STEAM-REFINED ASPHALTS IN EXPERIMENTAL
ANIMALS & INSUFFICIENT EVID OF CARCIN FOR UNDILUTED (ING 7)
Ingred Name:ING 6:STEAM-REFINED ASPHALTS IN HUMANS. THESE ASPHALT
SOURCES ARE NOT CONSTITUENTS OF CIM PREMIX.
Ingred Name:FIRST AID PROC:DOCTOR. INGEST:GIVE WATER/MILK TO DRINK &
Ingred Name:ING 8:VOMIT. IF MED ADVICE CANNOT BE OBTAINED, THEN TAKE
PERSON & PROD CNTNR TO NEAREST MED EMER TREATMENT CTR/HOSPITAL.
Ingred Name:SPILL RELEASE:MATL, IF NOT ACTIVATED W/CIM ACTIVATOR, MAY
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYES:MAY CAUSE IRRIT. SKIN:MAY
CAUSE IRRIT. INHAL:BRTHG SOLV VAP CAN CAUSE CNS EFTS INCLDG DIZZ,
WEAK, FATG, & HDCH & POSS UNCON & EVEN DEATH. INGEST:MATL CNTNS
LIGHT HYDROCARBON LIQ. ASPIR HAZ MAY EXIST WHICH COULD CAUSE CHEM
PNEUM WHICH IS SOMETIMES FATAL. INGEST CAN CAUSE GI IRRIT, NAUS,
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:VOMIT & DIARR. CIM PREMIX IS USED
W/CIM ACTIVATOR TO FORM ELASTOMERIC COATING FOR WATERPROOFING &
CORR PROT. CONSULT MSDS FOR CIM ACTIVATOR. AVOID INHAL OF ACTIVATED
CIM MIX WHICH CNTNS ISOCY ANATES & MAY RSLT IN SENSIT & ALLERGIC
RESPONSE IN SOME INDIVIDUALS. NO ASSOC HAS BEEN ESTABLISHED BETWEEN
INDUST(ING 5)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
HOLDING EYELIDS OPEN. IF IRRIT PERSISTS, SEE DOCTOR. SKIN:REMOVE
HEAVILY CONTAMD CLTHG & WASH SKIN THORO W/SOAP & WATER. DO NOT USE
SOLV/THINNER S TO REMOVE MATLS FROM SKIN. ASPHALT CAN BE REMOVED
W/VEGETABLE OIL/MINERAL OIL. INHAL:MOVE PERSON TO FRESH AIR & APPLY
OXYG IF BRTHG IS DFCLT. IF BRTHG HAS STOPPED, APPLY ARTF RESP. CALL
(ING 8)
* Fire Fighting Measures *
Lower Limits:1%
Upper Limits:6%
Extinguishing Media:CO*2, DRY CHEMICAL, FOAM, WATER FOG, HALON.
Fire Fighting Procedures:NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP . SEE
HAZARDOUS DECOMPOSITION PRODUCTS. READ THE ENTIRE MSDS.
Unusual Fire/Explosion Hazard:FLAM LIQ:SOLVS CNTND IN PROD EVAP & FORM
VAP (FUMES) WHICH CAN CATCH FIRE & BURN W/EXPLO VIOLENCE. INVISIBLE
VAP SPREADS EASILY & CAN BE SET ON FIRE BY (SUPDAT)
* Accidental Release Measures *
Spill Release Procedures:ELIM ALL OPEN FLAME IN VICIN OF SPILL/RELEASED
VAP. CLEAN UP SM SPILLS USING APPROP TECHNIQUES SUCH AS ABSORB
MATLS/PUMPING. WHERE FEASIBLE & APPROP, REMOVE CONTAMD SOIL. FOLLOW
PRESCRIBED PROC FOR RP TG & RESPONDING TO LARGER RELEASES. THIS
*Handling and Storage *
Handling and Storage Precautions:READ & OBSERVE ALL PRECAUTIONS ON PROD
LBL. DO NOT USE/STORE NEAR FLAME, SPARKS OR HOT SURFACES. USE ONLY
WELL VENTILATED AREA. KEEP CONTAINER CLOSED.
Other Precautions:DO NOT WELD, HEAT/DRILL CNTNR. REPLACE CAP/BUNG.
EMPTIED CNTNR STILL CONTAINS HAZARDOUS/EXPLO VAPOR OR LIQUID.
CAUTION!DO NOT USE PRESSURE TO EMPTY DRUM OR EXPLOSION MAY RESULT.
HAZARDS:MANY SOURCES SUCH AS CIGARETTES, PILOT LIGHT, WELDING
EQUIPMENT,ELEC MOTORS & SWITCHES, & STATIC DISCHARGE. FIRE HAZARD
IS GREATER AS LIQUID TEMP RISES.
* Physical/Chemical Properties *
Vapor Density:4.9
Evaporation Rate & Reference:NOT KNOWN.
Solubility in Water:SUPP DATA
Appearance and Odor:BLACK LIQUID WITH KEROSENE ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
MAY REACT WITH STRONG OXIDIZING MATERIALS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:INCOMPLETE COMBUST CAN PRDCE CO. NORM
COMBUST FORMS CO*2 & WATER VAP & MAY PRDCE OXIDES OF NITROGEN.
* Disposal Considerations *
Waste Disposal Methods:PLACE CONTAMD MATLS IN DISPOSABLE CNTNRS &
DISPOSE OF IN MANNER CONSISTENT W/APPLIC REGS. CONTACT FEDERAL,
STATE & LOCAL ENVIRON OR HEALTH AUTH FOR APPROVED DISPOSAL OF THIS
MATERIAL.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:SUPPLIED AIR W/FULL FACEPIECE,HELMET OR HOOD
Ventilation:LOCAL EXHAUST
Other Protective Equipment:FULL CLOTHING TO PREVENT SKIN CONTACT
Supplemental Safety and Health
OVEREXPOS:CAN CAUSE FORMATION OF CYSTS,CAUSES
STILLBIRTHS.IRRITATES,EYES,NOSE,THROAT.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:POLYCHLORINATED BIPHENYLS (PCBS) (SARA III)
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
* Hazards Identification *
Effects of Overexposure:ABSORBED THRU SKIN,LUNGS,INTESTINE.CAUSES
CANCER,LIVER,KIDNEY,STOMACH,EYE,HEARING DISORDER(SUP DATA)
* First Aid Measures *
First Aid:EYES:FLUSH W/WATER IMMEDIATELY.SKIN:WASH W/SOAP
IMMED.INHAL:REMOVE TO FRESH AIR,GIVE ART.RESPIR.AS
NEEDED.INGEST:GET MEDICAL ATTN.GIVER LARGE QTY OF SALT WATER,INDUCE
VOMITING,BUT DO NOT MAKE UNCONSCI OUS PERSON VOMIT.
* Accidental Release Measures *
Spill Release Procedures:USE ABSORBENT & DIKES TO PREVENT
RUNOFF.ISOLATE & NOTIFY PROPER AUTHORITIES.
*Handling and Storage *
Handling and Storage Precautions:STORAGE MUST FOLLOW RCRA REQUIREMENTS.
* Physical/Chemical Properties *
HCC:T6
Appearance and Odor:LIGHT STRAW-COLORED LIQUID,AROMATIC ODOR.
* Stability and Reactivity Data *
STRONG OXIDIZERS
* Disposal Considerations *
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-GENERALLY HIGH
TEMPERATURE INCINERATION.ONLY APPROVED DISPOSAL OPERATOR PERMITTED.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IN OPEN AREAS W/UNRESTRICTED VENT, USE NIOSH
APPROVED FILTER RESPIRATOR TO REMOVE SOLID AIRBORNE PART OVERSPRAY
DURING SPRAY APPLICATION. IN RESTRICTED VENT AREAS, USE NIOSH
APPROVED RESPIRATOR TO REM OVE COMBINATION OF PARTICULATE & VAPOR.
Ventilation:VENT TO KEEP TLV/LEL OF HAZARD INGRED BELOW LIM & REMOVE
DECOMP PROD DURING WELD/FLAME CUT ON SURFACES COATED W/PRODUCT.
Other Protective Equipment:WEAR APPROPRIATE IMPERVIOUS PROTECTIVE
CLOTHING TO PREVENT SKIN CONTACT.
Work Hygienic Practices:REMOVE AND WASH SOILED CLOTHING BEFORE REUSE.
WASH HANDS BEFORE EATING OR SMOKING.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
Ingred Name:METHYL ISOBUTYL KETONE (SARA III)
Ingred Name:TRICRESYL PHOSPHATE (TAR ACD, CRESYL, PHNYL, PHSPHA)
Fraction by Wt: 1-5%
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: SEVERE IRRITATION, REDNESS,
TEARING AND BLURRED VISION. SKIN: IRRITATING. MAY RESULT IN
DERMATITIS. HARMFUL IF ABSORBED THROUGH SKIN. INHALATION: SEVERE
IRRITATION. INGESTION: GASTROINTESTINAL I RRITATION. CHRONIC
OVEREXPOSURE TO AND MISUSE OF SOLVENTS HAS BEEN LINKED TO PERMANENT
BRAIN AND NERVOUS SYSTEM DAMAGE.
Effects of Overexposure:INGESTION: NAUSEA, VOMITING, DIARRHEA AND
UNCONSCIOUSNESS. INHALATION: DIZZINESS, POSSIBLE NAUSEA, VOMITING
AND UNCONSCIOUSNESS.
Medical Cond Aggravated by Exposure:SKIN AND RESPIRATORY CONDITIONS.
* First Aid Measures *
MINUTES. GET MEDICAL ATTENTION IMMEDIATELY. SKIN: REMOVE
CONTAMINATED CLOTHING, WASH SKIN W/PLENTY OF SOAP & WATER. LAUNDER
CLOTHES BEFORE REU SE. INHALATION: REMOVE TO FRESH AIR. GIVE CPR IF
NEEDED. GET MEDICAL ATTENTION. INGESTION: GET MEDICAL ATTENTION
IMMEDIATELY. DRINK PROMPTLY MILK, EGG WHITES, GELATIN SOL'N OR
WATER. AVOID ALCOHOL.
* Fire Fighting Measures *
Lower Limits:1
Extinguishing Media:FOAM, CO2 AND DRY CHEMICAL.
Fire Fighting Procedures:SMOTHER FLAMES W/EXTINGUISHING MEDIA. USE
WATER TO COOL UNOPENED CONTAINERS, BUT DO NOT USE AS EXTINGUISHING
MEDIA. PREVENT SPREAD OF BURNING LIQUID W/WATER.
Unusual Fire/Explosion Hazard:CONTAINS FLAMMABLE SOLVENT. DO NOT USE IN
AREAS WHERE SPARK OR OPEN FLAME ARE PRESENT. CLOSED CONTAINERS MAY
EXPLODE W/HEAT.
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. AVOID
INHALATION OF VAPORS. VENTILATE AREA. CLEAN UP WITH ABSORBENT
MATERIALS.
*Handling and Storage *
Handling and Storage Precautions:STORE IN BUILDING W/NFPA CLASS GIVEN
BY OSHA CLASS IN SECTION 4. AVOID BREATHING DUST OR CHIPS FROM
SANDING/BLASTING SURFACES COATED W/THIS PRODUCT.
MATERIAL IS TOXIC TO FISH IF MISUSED. READ CONTAINER LABEL BEFORE
USE.
* Physical/Chemical Properties *
Vapor Density:>AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
MOISTURE AND OXIDIZING AGENTS.
Stability Condition to Avoid:KEEP DRY. STORE AWAY FROM DIRECT HEAT,
FLAME OR SPARK.
Hazardous Decomposition Products:CO, CO2, VARIOUS HYDROCARBON
FRAGMENTS, ZINC FUMES AND COPPER FUMES.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. DO NOT INCINERATE UNOPENED CONTAINERS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE
Other Protective Equipment:APRON DESIRABLE
Supplemental Safety and Health
UNDAED MSDS.-
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:TRIETHANOL AMINE LAURYL SULFATE
Ingred Name:WATER
Ingred Name:NO HAZARDOUS COMPONENTS PER MANUFACTURER.
* Hazards Identification *
Effects of Overexposure:NONE
* First Aid Measures *
First Aid:IN CASE OF CONTACT,IMMEDIATELY FLUSH EYES OR SKIN W/PLENTY OF
WTR.
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:NO SPECIAL PROCEDURES.
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
Spill Release Procedures:FLUSH WITH WATER.
*Handling and Storage *
Handling and Storage Precautions:STORE IN ROOM TEMPERATURE
Other Precautions:AVOID ALKALIES
* Physical/Chemical Properties *
HCC:N1
Spec Gravity:1.0
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR LIQUID/CHARACTERISTIC ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRG.OXIDIZING & REDUCING AGTS.ALKALIES.
Hazardous Decomposition Products:TRIETHANOLAMINE.
* Disposal Considerations *
Waste Disposal Methods:FLUSH TO SEWER IF PERMITTED.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR.CONFINED
AREA,AIRLINE HOOD-TYPE RESP.
Ventilation:LOCAL EXHAUST/MECH TO KEEP BELOW TLV LIMIT.
Other Protective Equipment:PROT CLOTH,SHOE COVER.CONFINE
AREA:EXPLOS,SPARK-PROOF EQUIP.
Supplemental Safety and Health
DAMAGE.SKIN,EYE:BURNS,INJURY.PART A OF A 2 PART KIT.CALL MFR FOR
* Product Identification *
Kit Part:Y
* Composition/Information on Ingredients *
Ingred Name:N-PROPYL ALCOHOL
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
Fraction by Wt: 9%
* Hazards Identification *
Effects of Overexposure:IRRIT:SKIN,MUC MEMB,EYE,RESP
SYS.INHAL:HDCH,NAUS,DIZ,ASPHYXIA.VAPOR,SPRAY,MIST CAN BE
HARMFUL.SUPP
* First Aid Measures *
First Aid:INHAL:FRESH AIR.GIVE O*2,CPR.SKIN:WASH W/ 5% CH*3COOH THEN
AND GET MEDICAL ATTENTION.LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.INGEST: DO NOT INDUCE VOMITING.CALL PHYSICIAN IMMEDIATELY.
* Fire Fighting Measures *
Lower Limits:1.1
Extinguishing Media:FOAM,CO*2,DRY CHEMICAL
Unusual Fire/Explosion Hazard:ISOLATE FROM HEAT,ELECTRICAL
EQUIPMENT,SPARKS AND OPEN FLAME.WEAR SELF-CONTAINED BREATHING
APPARATUS
* Accidental Release Measures *
Spill Release Procedures:ELIMINATE ALL SOURCES OF IGNITION.USE
ABSORBENT CLEANUP MATERIALS.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER CLOSED.STORE IN
COOL,DRY,WELL-VENTILATED AREA.
Other Precautions:AVOID PROLONGED BREATHING OF VAPORS OR SPRAY MIST OR
CONTACT WITH SKIN AND EYES,DESTROY ALL LEATHER MATERIAL WHICH
CANNOT BE DECONTAMINATED.
* Physical/Chemical Properties *
HCC:F3
Vapor Density:>1
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NEGLIGIBLE
Appearance and Odor:GRAY LIQUID,SOLVENT ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS,EPOXY RESIN UNDER UNCONTROLLED CONDITIONS.
Stability Condition to Avoid:HEAT,OPEN FLAME ARC OR SPARKS
Hazardous Decomposition Products:CO AND CO*2
* Disposal Considerations *
Waste Disposal Methods:IN SEPARATE CLOSED METAL CONTAINER IN ACCORDANCE
WITH LOCAL,STATE AND FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE NORMALLY REQUIRED. USE NIOSH/MSHA APPROVED
RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:LOCAL EXHAUST/MECHANICAL(GENERAL): ACCEPTABLE.
Other Protective Equipment:COVERALLS RECOMMENDED.
Work Hygienic Practices:WASH EXPOSED AREAS THORO BEFORE EATING,
DRINKING, SMOKING, OR LEAVING WORK AREA. LAUNDER CONTAMD CLTHG
BEFORE REUSE.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
Product ID:RECTORSEEK MID-TEMP
* Composition/Information on Ingredients *
Ingred Name:NONHAZARDOUS INGREDIENTS
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE/CHRONIC: NONE KNOWN. EYES:
IRRITATION, WATERING. INHAL: NOT APPLICABLE. INGEST: MAY CAUSE
NAUSEA AND VOMITING. NOT EXPECTED TO PRODUCE TOXIC EFFECTS UNLESS
LARGE AMOUNTS INGESTED. SKIN: IRRITATI ON.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:
* First Aid Measures *
MINUTES ONLY IF CONSCIOUS. SEEK IMMEDIATE MEDICAL ATTENTION. INHAL:
REMOVE TO FRESH AIR. SUPPORT BRTHG (GIVE O*2/ARTF RESP) . INGEST:
INDU CE VOMITING. GIVE LARGE AMOUNTS OF WATER ONLY IF CONSCIOUS.
SEEK IMMEDIATE MEDICAL ATTENTION. SKIN: WASH WITH SOAP AND WATER.
IF IRRITATION OCCURS, SEEK MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:FOAM, DRY CHEMICAL, CARBON DIOXIDE, OR WATER FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:FOAM OR WATER CAN CAUSE FROTHING. HEAT
MAY BUILD UP PRESSURE AND RUPTURE CLOSED CONTAINERS.
* Accidental Release Measures *
Spill Release Procedures:WIPE UP SPILLS TO PREVENT FOOTING HAZARD.
AVOID FLUSHING INTO SEWERS, DRAINS, WATERWAYS AND SOIL. WEAR
PROTECTIVE CLOTHING DURING CLEANUP.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER CLOSED AND UPRIGHT WHEN
NOT IN USE.
Other Precautions:AVOID PRLNGD/RPTD CONT W/SKIN/CLTHG. EMPTY CONTAINERS
MAY CONTAIN RESIDUES AND VAPORS; TREAT AS IF FULL AND OBSERVE ALL
PRODUCT PRECAUTIONS. DO NOT REUSE EMPTY CONTAINERS. KEEP OUT OF
REACH OF CHILDRE N.
* Physical/Chemical Properties *
Vapor Density:>1
Spec Gravity:1(H*2O=1)
Evaporation Rate & Reference:1(ETHYL ETHER=1)
Solubility in Water:SOLUBLE
Appearance and Odor:CLEAR BLUE LIQUID/ODORLESS.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY YIELD CARBON
MONOXIDE, CARBON DIOXIDE.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF CLEANUP MATERIALS AND LIQUID WASTE IN
CONTROLLED INCINERATION FACILITIES IN ACCORDANCE WITH ALL LOCAL,
STATE AND FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE SUPPLIED-AIR RESPIRATORY PROTECTION IN
CONFINED OR ENCLOSED SPACES, IF NEEDED.
Ventilation:USE ONLY WITH VENTILATION SUFFICIENT TO PREVENT EXCEEDING
RECOMMENDED EXPOSURE LIMIT OR BUILDUP OF EXPLOSIVE CONCENTRATI
Work Hygienic Practices:MINIMIZE BREATHING VAPOR OR MIST. AVOID
PROLONGED OR REPEATED CONTACT WITH SKIN. REMOVE CONTAMINATED
CLOTHING; LAUNDER D
Supplemental Safety and Health
* Product Identification *
Product ID:JOBBER SUPREME GASOLINE
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Effects of Overexposure:HIGH VAPOR CONCENTRATIONS (GREATER THAN
RESPIRATORY TRACT, MAY CAUSE HEADACHES AND DIZZINESS, ARE
ANESTHETIC, MAY CAUSE UNCONSCIOUSNESS, ANDMAY HAVE OTHER CENTRAL
NERVOUS SYSTEM EFFECT INCLUDING DEATH.
Medical Cond Aggravated by Exposure:BENZENE-INDIVIDUALS WITH LIVER
DISEASE MAY BE MORE SUSCEPTIBLE TO TOXIC EFFECTS.
HEXANE-INDIVIDUALS WITH NEUROLOGICAL DISEASE SHOULD AVOID EXPOSURE.
PETROLEUM SOLVENTS/PETROLEUM HYDROCARBONS-SKIN CONT
* First Aid Measures *
First Aid:EYE CONTACT-IF SPLASHED INTO THE EYES, FLUSH WITH CLEARWATER
CONTACT, REMOVE ALL CONTAMINATED CLOTHING AND WASH SKIN THOROUGHLY
WITH S OAP AND WATER. INHALATION-IF OVERCOME BY VAPOR, REMOVE FROM
EXPOSURE AND CALL A PHYSICIAN IMMEDIATELY. INGESTION-IF INGESTED,
DO NOT INDUCE VOMITING; CALL A PHYSICIAN IMMEDIATELY.
* Fire Fighting Measures *
Extinguishing Media:USE FOAM, WATER SPRAY (FOG), DRY CHEMICAL, CARBON
DIOXIDE AND VAPORIZING LIQUID TYPE EXTINGUISHING AGENTS MAY ALL BE
SUI
Fire Fighting Procedures:IF A LEAK OR SPILL HAS IGNITED, USE WATER
SPRAY TO DISPERSE THE VAPORS AND TO PROTECT MEN ATTEMPTING TO STOP
A LEAK. WATER SPRAY MAY BE USED TO FLUSH SPILLS AWA
* Accidental Release Measures *
Spill Release Procedures:SHUT OFF AND ELIMINATE ALL IGNITION SOURCES.
KEEP PEOPLE AWAY. RECOVER FREE PRODUCT. ADD SAND, EARTH OR OTHER
SUITABLE ABSORBENT TO SPILL AREA. MINIMIZE BREATHING VAPORS.
MINIMIZE SKIN CONTACT. VENTIL ATE CONFINED SPACES. OPEN ALL WINDOWS
AND DOORS.
*Handling and Storage *
Handling and Storage Precautions:KEEP PRODUCT AWAY FROM HEAT, SPARKS,
PILOT LIGHTS, STATIC ELECTRICITY, AND OPEN FLAME.
Other Precautions:STORE AWAY FROM CHILDREN.DON'T TAKE INTERNALLY.AVOID
CONTACTWITH SKIN, EYES, AND CLOTHING.
* Physical/Chemical Properties *
Vapor Density:APPROX. 5
pH:NEUTRA
Solubility in Water:NEGLIGIBLE; <0.1%
Appearance and Odor:CLEAR COLORED LIQUID (TYPICALLY RED) GASOLINE
HYDROCARBON ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDANTS SUCH AS LIQUID CHLORINE,
CONCENTRATED OXYGEN, SODIUM HYPOCHLORITE OR CALCIUM HYPOCHLO
Hazardous Decomposition Products:FUMES, SMOKE, CARBON MONOXIDE,
ALDEHYDES AND OTHER DECOMPOSITION PRODUCTS, IN THE CASE OF
INCOMPLETE COMBUSTION.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF INACCORDANCE WITH STATE,LOCAL,FEDERAL
REGS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF LEVELS EXCEED THE RECOMMENDED HEALTH
STANDARDS, WEAR A NIOSH/MSHA APPROVED ORGANIC VAPOR RESPIRATOR. FOR
EMERGENCY USE, WEAR A NIOSH APPROVED SELF-CONTAINED BREATHING
APPARATUS.
Ventilation:IF LEVELS EXCEED THE RECOMMENDED HEALTH STANDARDS, USE
LOCAL EXHAUST OR GENERAL DILUTION VENTILATION.
Other Protective Equipment:EYE WASH STATION & SAFETY SHOWERS SHOULD BE
AVAILABLE IN THE IMMEDIATE VICINITY OF ANY POTENTIAL EXPOSURE.
Work Hygienic Practices:WASH HANDS BEFORE EATING, DRINKING, SMOKING, OR
USING TOILET FACILITIES. WASH CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
NONE
* Product Identification *
Product ID:IBM, SOLVENT, ANTI STATIC LIQUID
* Composition/Information on Ingredients *
Ingred Name:ISOPROPYL ALCOHOL (SARA III)
Other REC Limits: SPECIFIED
Ingred Name:WATER
Other REC Limits: SPECIFIED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:
INHALATION/INGESTION-DRUNKENNESS, DROWSINESS, INCOORDINATION.
EYE/SKIN-MILD IRRITATION. CHRONIC: INHALATION-DROWSINESS OR
DRUNKENNESS.
Effects of Overexposure: SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure: SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:OBTAIN MEDICAL ATTENTION. INGESTION: IF CONSCIOUS & IF THERE
ARE NO SIGNS OF CONVULSIONS/GAG REFLEX IMPAIRMENT, INDUCE VOMITING.
INHALATION: REMOVE FROM EXPOSURE. IF BREATHING IS DIFFICULT/ABSENT,
MINUTES. SKIN: WASH WITH MILD SOAP & WATER.
* Fire Fighting Measures *
Flash Point Method:CC
Lower Limits:2.5
Extinguishing Media:CARBON DIOXIDE, FOAM, OR DRY CHEMICAL.
Fire Fighting Procedures:WATER SPRAY DOES NOT EFFECTIVELY EXTINGUISH A
FIRE, BUT WILL HELP TO COOL CONTAINERS.
Unusual Fire/Explosion Hazard:HIGHLY FLAMMABLE LIQUID.
* Accidental Release Measures *
Spill Release Procedures:ELIMINATE ALL SOURCES OF IGNITION. VENTILATE
AREA. AVOID BREATHING OF VAPORS. COVER WITH ABSORBENT MATERIAL,
COLLECT THE MIXTURE AND PLACE IN A CLOSED CONTAINER FOR PROPER
DISPOSAL.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINERS TIGHTLY CLOSED. STORE
AWAY FROM HEAT, SPARKS OR OPEN FLAMES.
Other Precautions:KEEP OUT OF REACH OF CHILDREN.
* Physical/Chemical Properties *
HCC:F3
Spec Gravity:0.3
Appearance and Odor:CLEAR, WATER WHITE LIQUID; SWEET ALCOHOL ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDANTS.
Stability Condition to Avoid:HEAT, OPEN FLAMES, SPARKS.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE AND
UNIDENTIFIED ORGANICS
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. USE CERTIFIED VENDOR FOR DISPOSAL BY
INCINERATION.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR RESPIRATORY PROTECTIVE EQUIPMENT WHEN
EXPOSED TO DUST LEVELS THAT EXCEED THE ESTIMATED SAGE WORKING LEVEL
MANUFACTURER'S RECOMMEND ATIONS.
Ventilation:PROVIDE LOCAL EXHAUST VENTILATION SYSTEM AT THE SOURCE OF
DUST GENERATION.
Other Protective Equipment:A PROTECTIVE OUTER GARMENT IS ADEQUATE FOR
LOW DUST EXPOSURE. FOR HIGH EXPOSURE, WEAR WEAR FULL BODY
PROTECTION.
Work Hygienic Practices:ALL SKIN CONTACT SHOULD BE AVOIDED. EMPLOYEES
EXPOSED TO DUST SHOULD CHANGE CLOTHES & SHOWER AT END OF WORK
ASSIGNMENT.
Supplemental Safety and Health
NONE
* Product Identification *
Product ID:CEFUROXIME SODIUM
Preparer's Name:DIRECTOR, ENVIRON SAFETY
* Composition/Information on Ingredients *
Ingred Name:CEFUROXIME SODIUM
Other REC Limits:0.1 MG/M3 (MFR)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ZINACEF IS A CEPHALOSPORIN ANTIBIOTIC
USED TO TREAT BACTERIAL INGECTIONS DUE TO SUSCEPTIBLE ORGANISMS.
ACUTE DUST EXPOSURE MAY CAUSE MILD TO SEVERE ALLERGIC REACTIONS IN
SENSITIVE INDIVIDUALS. THERE I S NO RECORDED FATAL ANAPHYLAXIS, BUT
ITIS A POSSIBILITY. MAY BE A SKIN SENSITIZER.
Explanation of Carcinogenicity:THERE IS NO PUBLISHED EVIDENCE THAT THE
COMPOUND IS CARCINOGENIC OR TERATOGENIC. WAS NEGATIVE ON THE
MUTAGENIC AMES TEST
Effects of Overexposure:INHALED:RESPIRATORY IRRITATION,ITCHY SKIN
RASHES,HIVES,RUNNY/STUFFY NOSE,CHEST TIGHTNESS,SWELLING & DIFFICULT
BREATHING. SKIN:SENSITIZER. RED ITCHY SKIN RASH AFTER REPEATED
CONTACT.
Medical Cond Aggravated by Exposure:ALLERGIC REACTIONS MAY OCCUR IN
INDIVIDUALS SENSITIVE TO CEPHALOSPORINS, PENICILLLINS OR RELATED
COMPOUNDS.
* First Aid Measures *
First Aid:EYE:FLUSH THOROUGHLY W/LARGE AMOUNT OF WATER. GET MEDICAL
ATTENTION. SKIN:REMOVE CONTAMINATED CLOTHING & WASH W/SOAP & WATER.
INHALED:REMOVE VICTIM TO FRESH AIR. IF BREATHING IS DIFFICULT OR
CEASES, G IVE OXYGEN OR CPR. GET MEDICAL ATTENTION. INGESTED:RINSE
MOUTH WITH WATER. GET MEDICAL ATTENTION.
* Fire Fighting Measures *
Extinguishing Media:WATER SPRAY, FOAM, MULTI-PURPOSE DRY CHEMICAL.
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING AND USE SELF
CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:AS WITH ANY ORGANIC DUST, THERE IS
POTENTIAL FOR EXPLOSION WHEN SUSPENDED IN AIR IN HIGH
CONCENTRATIONS.
* Accidental Release Measures *
Spill Release Procedures:WEAR FULL PROTECTIVE EQUIPMENT. AVOID BODY
CONTACT AND/OR BREATHING DUST. COLLECT SPILLAGE BY CAREFULLLY
SWEEPING OR VACUUMING WITH HEPA FILTEREDVACUUM & PLACE IN LABELED,
SEALED CONTAINER FOR REUSE O R DISPOSAL. WASH AREA AFTER VACUUMING.
Neutralizing Agent:MFR GAVE NO INFORMATION ON MSDS.
*Handling and Storage *
Handling and Storage Precautions:USE STORAGE PRACTICES THAT WILL
MINIMIZE GENERATION OF DUST.
Other Precautions:SPECIAL CARE SHOULD BE TAKEN TO INSURE THAT
CONTAMINATED CLOTHING & EQUIPMENT ARE PROPERLY CLEANED AFTER USE.
* Physical/Chemical Properties *
HCC:N1
NRC/State Lic Num:
Appearance and Odor:WHITE TO CREAMY WHITE POWDER, ODOR NOT LISTED
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NO KNOWN INCOMPATIBILITIES.
Stability Condition to Avoid:SLIGHTLY UNSTABLE IN AIR & WILL SLOWLY
DECOMPOSE. THE MATERIAL SHOULD BE PROTECTED FROM LIGHT AND STORED
UNDER NITROGEN.
Hazardous Decomposition Products:THERMAL DECOMPOSITION PRODUCTS INCLUDE
TOXIC & CORROSIVE OXIDES OF NITROGEN AND SULFUR.
* Disposal Considerations *
Waste Disposal Methods:INCINERATE AT AN APPROVED FACILITY I/A/W
FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WHERE ENVIRONMENTAL CONTROLS ARE LACKING OR IN
ENCLOSED SPACES USE A SELF-CONTAINED BREATHING APPARATUS.
Ventilation:LOCAL VENTILATION(EXPLOSION-PROOF EQUIPMENT) AT THE
WORKSITE;MECHANICAL(GENERAL) VENTILATION TO MAINTAIN TLV/PEL.
Other Protective Equipment:INDUSTRIAL WORK CLOTHING TO MINIMIZE
CONTACT. RUBBER APRON AD BOOTS AS REQUIRED. EYE BATH AND SAFETY
SHOWER RECOMMENDED.
Work Hygienic Practices:WASH THOROUGHLY AFTER USING PRODUCT AND BEFORE
EATING, DRINKING OR SMOKING. LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
NONE
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATES, HYDROTREATED LIGHT
NAPHTHENIC
Other REC Limits: SPECIFIED
ACGIH TLV:5 MG/M3 (OIL MIST)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL:MISTS/VAPORS MAY CAUSE NOSE OR
THROAT IRRITATION.INGEST:MAY CAUSE ABDOMINAL DISCOMFORT.MAY CAUSE
LUNG DAMAGE IF VOMITED AFTER SWALLOWING.EYES:MAY CAUSE MINIMAL
IRRITATION.SKIN:PROLONGED CONTACT MAY CAUSE IRRITATION,DEFATTING.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of
Overexposure:INHAL:HEADACHE,NAUSEA,DROWSINESS.INGEST:NAUSEA,DIARRHE
A.SKIN:LOCAL REDNESS,MILD DISCOMFORT.
Medical Cond Aggravated by Exposure:BECAUSE OF ITS DEFATTING
PROPERTIES,PERSON WITH EXISTING DERMATITIS MAY BE ADVERSELY
AFFECTED.
* First Aid Measures *
First Aid:SKIN:REMOVE CONTAMINATED CLOTHING;WASH WITH SOAP AND
AIR.GIVE OXYGEN OR ARTIFICIAL RESPIRATION IF NEEDED.INGEST:GET
PROMPT QUALIFIED ME DICAL ATTENTION.INDUCE VOMITING ONLY UNDER THE
ADVICE OF A PHYSICIAN.
* Fire Fighting Measures *
Flash Point Method:COC
Extinguishing Media:WATER SPRAY,DRY CHEMICAL,FOAM,CARBON DIOXIDE.WATER
OR FOAM MAY CAUSE FROTHING.
Fire Fighting Procedures:USE A SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE EQUIPMENT.COOL FIRE EXPOSED CONTAINERS AND DISPURSE
VAPORS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:
* Accidental Release Measures *
Spill Release Procedures:VENTILATE AREA.USE PROPER RESPIRATORY AND
PROTECTIVE EQUIPMENT FOR LARGE LEAK.DIKE.SOAK UP WITH A
NON-COMBUSTIBLE INERT ABSORBANT(CLAY,SAND);PLACE IN PROPER
CONTAINER FOR DISPOSAL.WASH SPILL AREA TO R EMOVE SLIPPINESS.DO NOT
FLUSH TO SEWER.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:MAINTAIN MINIMUM FEASIBLE HANDLING
TEMPERATURE.PERIODS OF HIGH TEMPERATURE SHOULD BE AVOIDED.AVOID
WATER CONTAMINATION.
Other Precautions:"EMPTY" CONTAINERS CAN CONTAIN EXPLOSIVE VAPORS. DO
NOT CUT, DRILL, GRIND, WELD OR PERFORM SIMILAR OPERATIONS ON OR
NEAR CONTAINERS.
* Physical/Chemical Properties *
HCC:V6
Solubility in Water:NEGLIGIBLE
Appearance and Odor:LIQUID;LIGHT PALE
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HEAT OR COMBUSTION.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON
DIOXIDE,IRRITATING ALDEHYDES AND KETONES.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL,STATE AND
LOCAL REGULATIONS.UNUSED PRODUCT IS NOT RCRA HAZARDOUS WASTE;USED
PRODUCT MAY BE HAZARDOUS WASTE.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPRVD SUPPLIED-AIR RESP W/FULL
FACEPIECE, HELMET/HOOD.SCBA W/FULL FACEPIECE.TYPE C SUPPLIED-AIR
RESP W/ FULL FACEPIECE OPERATED IN PRESS-DEMAND/OTHER POS PRESS
MODE/W/FULL FACEPIECE, HELME T/HOOD OPERATED IN CONTINUOUS-FLOW
MODE.
Ventilation:PROVIDE LOCAL EXHAUST OR PROCESS ENCLOSURE VENTILATION TO
MEET PUBLISHED EXPOSURE LIMITS.
Other Protective Equipment:APPROPRIATE PROT (IMPERVIOUS) CLOTHING &
EQUIPMENT. AN EYE WASH FOUNTAIN & QUICK DRENCH SHOWER W/IN IMMED
WORK AREA.
Work Hygienic Practices:CONTACT LENSES SHOULD NOT BE WORN.
Supplemental Safety and Health
FIRE FIGHT PROC:FIRE IS OUT.STAY AWAY FROM STOR TANK ENDS.FOR MASSIVE
FIRE IN STOR AREA, USE UNMANNED HOSE HOLDER/ MONITOR NOZ, ELSE
W/DRAW FROM AREA & LET FIRE BURN.W/DRAW IMMED IN CASE OF RISING SOU
ND FROM VENTING SAFETY DEVICE/ANY DISCOLORATION OF STOR TANK DUE TO
FIRE.EXTING ONLY IF FLOW CAN BE STOPPED; (ING 8)
* Product Identification *
* Composition/Information on Ingredients *
RESP/OLIGURIA/UREMIA/DIURESIS/COMA/DEATH BY RESP PARALYSIS.
Ingred Name:FIRST AID PROC:EYE:WASH IMMED W/LG AMTS OF WATER LIFTING
MD.INGEST:DO NOT INDUCE VOMIT.GET MD.NO ANTIDOTE.
Ingred Name:POPOP 1 ,4-BIS-2-(5-PHENYLOXAXOLYL)-BENZENE
Ingred Name:SUPP DATA:USE FLOODING AMTS OF WATER AS FOG, SOLID STREAMS
MAY BE INEFTIVE.COOL CNTNRS W/FLOODING AMTS OF WATER, (ING 9)
Ingred Name:ING 8:APPLY FROM AS FAR A DISTANCE AS POSS.AVOID BREATHING
VAPORS, KEEP UPWIND.
Ingred Name:EXPLO HAZ: IGNITION AND FLASH BACK.
Ingred Name:HLTH HAZ:CAUSE BONE MARROW DAM.ING 3:MAY CAUSE IRRIT. ING
EYE:ACUTE:ING 1:MAY CAUSE REDNESS, EDEMA, PAIN & POSS CORNEAL(ING
LACRIMATION. DIRECT CONT MAY CAUSE IRRIT, BURNS & PERM CORNEAL(ING
Ingred Name:BENZENE, 1,2,4-TRIMETHYL-; (1,2,4-TRIMETHYLBENZENE) (SARA
III)
Ingred Name:GLYCOLS, POLYETHYLENE-POLYPROPYLENE;
(POLYOXYETHYLENE-POLYOXYPROPYLENE BLOCK POLYMER)
Ingred Name:ISOPROPYL ALCOHOL (SARA III)
Ingred Name:OXAZOLE, 2,5-DIPHENYL-; (2,5-DIPHENYLOXAZOLE)
Ingred Name:BIS(MSB)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHAL:ACUTE:ING 1:MAY CAUSE CHEM
PNEUMONITIS @ CONT SITE, SORE THROAT, COUGHING, HDCH, DYSPNEA,
FATG, NARCOSIS & HEMORRHAGIC INFLAMM LESIONS OF MUC MEMB. ING 3:MAY
CAUSE IRRIT. ING 4:MAY CAUSE DIZZ, I NCOORDINATION, HDCH,
CONFUSION, PERSISTENT NAUS, HEMATEMESES, ABDOM PAIN, STUPOR,
HYPOTENSION, ANEMIA, (EFTS OF OVEREXP)
Explanation of Carcinogenicity:ISOPROPYL ALCOHOL: GROUP 1 (IARC).
Effects of Overexposure:HLTH HAZ:REFRACTORY NARCOSIS, AREFLEXIA,
DEPRESSED RESP, OLIGURIA FOLLOWED BY DIURESIS, & UREMIA. TENDERNESS
& EDEMA OF MUSCLES MAY ALSO OCCUR. SEV CASES MAY CAUSE COMA.
CHRONIC: ING 1:MAY CAUSE NERVO USNESS, TENSION, ANXIETY, ASTHMATIC
BRONCHITIS, PAIN IN LIMBS, PERIPHERAL NUMBNESS & PARESTHESIA. MAY
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INHAL:REMOVE TO FRESH AIR IMMED.IF BRTHG STOPPED, GIVE ARTF
RESP.MAINTAIN AIRWAY & BLOOD PRESS & ADMIN O2 IF AVAIL. KEEP
AFFECTED PERS WARM & @ REST. ADMIN OF O2 SHLD BE PERFORMED BY
QUALIFIED PERS, G ET MED ATTN IMMED.SKIN:REMOVE CONTAMD CLTHG &
SHOES IMMED. WASH AFFECTED AREA W/SOAP/MILD DETERGENT & LG AMTS OF
* Fire Fighting Measures *
Extinguishing Media:DRY CHEMICAL, CARBON DIOXIDE, HALON, WATER SPRAY OR
ALCOHOL FOAM.FOR LARGER FIRES: USE H2O SPRAY/FOG/ALCOHOL FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
.MOVE CNTNR FROM FIRE AREA IF POS. COOL FIRE-EXPOS CNTNRS W/ WATER
FROM SIDE UNTIL WELL AFTER (SUPP DATA)
Unusual Fire/Explosion Hazard:MOD FIRE & EXPLO HAZ WHEN EXPOS TO HEAT/
FLAME.VAP-AIR MIX ARE EXPLO >FL PT. VAPS ARE HVR THAN AIR & MAY
* Accidental Release Measures *
Spill Release Procedures:SHUT OFF IGNIT SOURCES.STOP LEAK IF W/OUT
RISK.USE WATER SPRAY TO REDUCE VAPS.SM:TAKE UP W/SAND/ABSORB &
PLACE INTO CNTNRS FOR DISP.LG:DIKE AHEAD OF SPILL FOR DISP.NO
SMOKING, FLAMES/FLARES IN HAZ ARE A.KEEP UNNEC PEOPLE AWAY.ISOLATE
& DENYENTRY.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
* Physical/Chemical Properties *
HCC:F4
Vapor Density:>1
Solubility in Water:SOLUBLE
Appearance and Odor:FAINT BLUE FLUORESCENT-HUED LIQUID.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NITRIC ACID, STRONG OXIDIZERS, FOR COMPLETE LISTING OF MATERIALS TO
AVOID CONTACT NEHC .
Stability Condition to Avoid:AVOID HEAT, NITRIC ACID, AND OXIDIZERS.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY RELEASE
ACRID SMOKE & IRRITATING FUMES. THERMAL DECOMP PRODS MAY INCLUDE
TOX OXIDES OF CARBON.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF I/A/W FEDERAL, STATE AND LOCAL
REGULATIONS .
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .AVOID BREATHING THE VAPORS OR FUMES OF THIS
PRODUCT.
Ventilation:LOCAL AND GENERAL VENTILATION NECESSARY TO KEEP AIR
CONCENTRATION BELOW TLV .
Other Protective Equipment:HAVE A SOURCE OF COOL,CLEAN WATER NEARBY IN
CASE OF ACCIDENTAL EYE OR SKIN CONTACT.
Work Hygienic Practices:DO NOT WEAR CONTACT LENSES WHILE WORKING WITH
THIS PRODUCT.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:PETROLEUM ASPHALT
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:5 MG/M3 (FUMES)
Ingred Name:ALIPHATIC PETROLEUM DISTILLATES
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:HARMFUL OR FATAL IF SWALLOWED.CONTAINS
PETROLEUM DISTILLATES.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES:DIRECT CONTACT WILL RESULT IN
IRRITATION.SKIN:PROLONGED OR REPEATED CONTACT MAY RESULT IN
IRRITATION.INGEST:HARMFUL OR FATAL IF SWALLOWED.CONTAINS PETROLEUM
DISTILLATES.INHAL:VAPOR MAY BE HARMFUL .
Medical Cond Aggravated by Exposure:N/K
* First Aid Measures *
First Aid:EYES:FLUSH IMMEDIATELY WITH PLENTY OF COOL WATER FOR AT LEAST
PROMPTLY WITH PLENTY OF SOAP AND WATER.IF IRRITATION
DEVELOPS,CONTACT PHYSI CIAN.INGEST:DO NOT INDUCE VOMITING.CONTACT
PHYSICIAN IMMEDIATELY.CONTAINS PETROLEUM DISTILLATES.INHAL:REMOVE
TO FRESH AIR.IF DIFFICULTY IN BREATHING OR OTHER SYMPTOMS
PERSIST,CONTACT A PHYSICIAN.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:N/K
Upper Limits:N/K
Extinguishing Media:CARBON DIOXIDE,FOAM OR DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .WATER MAY BE INEFFECTIVE BECAUSE OF THE
SOLVENT NATURE OF THIS PRODUCT.
Unusual Fire/Explosion Hazard:BURNING OF THIS MATERIAL MAY RESULT IN
THE FORMATION OF CARBON MONOXIDE AND/OR CARBON DIOXIDE GASES.
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL SOURCES OF HEAT,SPARKS OR OPEN
FLAMES.VENTILATE THE AREA OF THE SPILL.ABSORB ON STATE OIL
ABSORBENT,SAND OR VERMICULITE.FLUSH ANY RESIDUES WITH PLENTY OF
WATER AND A GOOD DETERGENT TO THE D RAIN.
Neutralizing Agent:N/K
*Handling and Storage *
Handling and Storage Precautions:HARMFUL OR FATAL IF SWALLOWED.VAPOR
MAY BE HARMFUL.AVOID DIRECT CONTACT WITH EYES OR
SKIN.COMBUSTIBLE.STORE AWAY FROM HEAT,SPARKS AND OPEN FLAMES.
Other Precautions:READ & FOLLOW ALL LABEL DIRECTIONS AND PRECAUTIONS
BEFORE USING.INTENDED FOR INDUSTRIAL AND INSTITUTIONAL USE
ONLY.KEEP OUT OF THE REACH OF CHILDREN.
* Physical/Chemical Properties *
Melt/Freeze Pt:M.P/F.P Text:N/K
Decomp Temp:Decomp Text:N/K
Vapor Pres:N/K
Vapor Density:N/K
Evaporation Rate & Reference:N/K
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLACK LIQUID WITH A PETROLEUM ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:EXPOSURE TO HEAT,SPARKS AND OPEN FLAMES.
Hazardous Decomposition Products:BURNING OF THIS MATERIAL MAY RESULT IN
THE FORMATION OF CARBON MONOXIDE AND/OR CARBON DIOXIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
* Disposal Considerations *
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH
FEDERAL,STATE AND LOCAL REGULATIONS .DO NOT REUSE EMPTY CONTAINERS
FOR ANY PURPOSE.FLUSH THOROUGHLY WITH WATER,CRUSH OR PERFORATE AND
DISCARD.GIVE RINSED DRUM S TO A DRUM RECONDITIONER FOR RECYCLING.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NOT NORMALLY REQUIRED. NIOSH/MSHA APPROVED
RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:GENERAL VENTILATION AS PER LOCAL OR STATE REGULATIONS.
Other Protective Equipment:APRON, FOOTWEAR & IMPERVIOUS CLTHG AS NEEDED
TO PVNT EXCESSIVE SKIN CONTACT. EMERGENCY EYEWASH & DELUGE SHOWER .
Work Hygienic Practices:WASH HANDS & FACE W/SOAP & WATER BEFORE EATING
OR SMOKING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
CAGE:0FTL5
CAGE:0FTL5
* Composition/Information on Ingredients *
Ingred Name:NON HAZARDOUS INGREDIENTS
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS: SKIN. EYES:CONTACT MAY
CAUSE BURNING & IRRITATION. SKIN:PROLONGED OR REPEATED EXPOSURE MAY
CAUSE IRRITATION OR DERMATITIS. INHAL:EXCESSIVE INHALATION OF
VAPORS MAY CAUSE HEADACHE, DIZZI NESS, DROWSINESS & NAUSEA.
INGEST:MAY CAUSE IRRITATION OR GASTRIC DISTURBANCE.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE.
* First Aid Measures *
IRRITATION PERSISTS, CONSULT MD. SKIN:WASH W/MILD SOAP & WATER.
INHAL:REMOVE TO FRESH AIR. APPLY ARTIFICIAL RESPIRATION &/OR OXYGEN
IF NEEDED. CO NSULT MD. INGEST:DO NOT INDUCE VOMITING. SEEK MEDICAL
AID.
* Fire Fighting Measures *
Flash Point Method:PMCC
Extinguishing Media:FOAM, CARBON DIOXIDE OR DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . WATER CAN BE USED TO KEEP MATERIAL COOL.
Unusual Fire/Explosion Hazard:DENSE SMOKE MAY BE GENERATED WHILE
BURNING.
* Accidental Release Measures *
Spill Release Procedures:WIPE UP SPILLS W/RAGS. DISPOSE OF RAGS IN
CONTAINER APPROVED FOR OILY WASTE.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINERS CLOSED WHEN NOT IN
USE. KEEP AWAY FROM EXCESSIVE HEAT, SPARKS & OPEN FLAME.
Other Precautions:DO NOT REUSE CONTAINER. FOR COMMERCIAL & INDUSTRIAL
USE ONLY. KEEP FROM REACH OF CHILDREN.
* Physical/Chemical Properties *
HCC:N1
Vapor Density:GREATER
Spec Gravity:<1 (H*2O=1)
Evaporation Rate & Reference:SLOWER (BUTYL ACETATE=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:COLORED PASTE; OILY ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
CONTACT W/STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:EXCESS HEAT.
Hazardous Decomposition Products:DENSE SMOKE, CARBON MONOXIDE & CARBON
DIOXIDE WHEN BURNING.
* Disposal Considerations *
Waste Disposal Methods:IN ACCORDANCE W/LOCAL, STATE & FEDERAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH APPROVED HIGH EFFICIENCY FIBERS/FUMES
RESPIRATOR WHEN AIRBORNE FIBER CONCENTRATIONS EXCEED THE PEL.
Ventilation:LOCAL/GENERAL TO MAINTAIN PEL/TLV. CHECK LOCAL REGULATIONS
FOR EMISSION STANDARDS.
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER, WORK
CLOTHING AND APRON AS REQUIRED. DO NOT WEAR CONTACT LENSES
Work Hygienic Practices:DON'T TAKE PROTECTIVE GEAR/CLOTHING HOME IF
EXPOSED TO DUST. DON'T SHAKE. DON'T EAT IN AREA WHERE ASBESTOS/DUST
PRESENT.
Supplemental Safety and Health
THERE ARE TWO MSDS FOR THIS NSN. THE NSN WAS ASSUMED TO BE FOR BOTH.
DID NOT HAVE INFORMATION OTHER THAN LINING, FRICTION. THE PRODUC T
MEETS THE OSHA DEFINITION OF AN ARTICLE AND IS EXEMPT FROM THE
HAZARDOUS COMMUNICATION STANDARD.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:ASBESTOS, CHRYSOTILE
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.2 FIBERS/CC
Ingred Name:TALC (CONTAINING ASBESTOS)
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.2 FIBERS/CC
Ingred Name:SILICA, CRYSTALLINE - TRIPOLI
Other REC Limits:NONE RECOMMENDED
OSHA PEL:SEE TABLE Z3
Ingred Name:SILICATES
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.1 MG/M3 (MFR)
ACGIH TLV:0.1 MG/M3 (MFR)
Ingred Name:CARBON BLACK
Other REC Limits:NONE RECOMMENDED
OSHA PEL:3.5 MG/M3
Ingred Name:GRAPHITE, NATURAL
Other REC Limits:NONE RECOMMENDED
Ingred Name:COAL DUST
Other REC Limits:NONE RECOMMENDED
OSHA PEL:2.0 MG/M3 (MFR)
ACGIH TLV:2.0 MG/M3 (MFR)
Ingred Name:COKE
Other REC Limits:NONE RECOMMENDED
OSHA PEL:2.0 MG/M3 (MFR)
ACGIH TLV:2.0 MG/M3 (MFR)
Ingred Name:PHENOLIC COMPOUND
Other REC Limits:NONE RECOMMENDED
Ingred Name:ELASTOMER
Other REC Limits:NONE RECOMMENDED
Ingred Name:WOOD FLOUR AND OTHER FILLER
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1.0 MG/M3 (MFR)
ACGIH TLV:1.0 MG/M3 (MFR)
Ingred Name:IRON,ZINC,ALUMINUM,BRASS AND THEIR OXIDES
Other REC Limits:NONE RECOMMENDED
Ingred Name:COPPER OXIDE
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.1 MG/M3 AS (CU)
ACGIH TLV:0.1 MG/M3 AS (CU)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE & CHRONIC-CASHEW-RESINS MAY
CAUSE DERMATITIS-TYPE PROBLEMS.DUST OF SILICA,TALC,GRAPHITE,CARBON
BLACK & COAL CAN CAUSE PNEUMOCONIOSIS & OTHER LUNG DAMAGE.METAL
DUSTS CAN IRRITATE EYES & UPPER RES PIRATORY TRACT.COPPER MAY CAUSE
KERATINIZATION & DISCOLORING OF THE SKIN.ASBESTOS CAUSES LUNG
CANCER.
Explanation of Carcinogenicity:ASBESTOS IS REGULATED BY OSHA AS A
CARCINOGEN. SMOKING INCREASES RISK OF CANCER.
Effects of Overexposure:CASHEW RESIN-SKIN
ERUPTIONS.PNEUMOCONIOSIS-COUGHING,WHEEZING,SHORTNESS OF
BREATH,IMPAIRED PULMONARY FUNCTION.DUSTS IN EYE MAY CAUSE
IRRITATION.GASTROINTESTINAL DISTURBANCES POSSIBLE FROM
INGESTION.COP PER MAY PRODUCE METALLIC TASTE IN MOUTHAND NAUSEA.
SMALL AMOUNTS OF INGESTED COPPER INDUCES VOMITING.
Medical Cond Aggravated by Exposure:NONE KNOWN
* First Aid Measures *
First Aid:SHOULD NOT BE NECESSARY FROM REASONABLE HANDLING OF THIS
PRODUCT. HOWEVER, SEEK MEDICAL ATTENTION IF SYMPTOMS DEVELOP. IN
KEEPING EY ELIDS OPEN. SKIN: WASH FREQUENTLY WITH SOAP AND WATER.
INHALATION: REMOVE TO FRESH AIR. INGESTION: UNLIKELY.
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:WATER, (CLASS A, B OR C). USE WATER SPRAY TO COOL
FIRE EXPOSED CONTAINERS
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING AND
NIOSH-APPROVED SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:TOXIC DECOMPOSITION FUMES OR ASBESTOS
FIBERS MAY BE EVOLVED IN A FIRE.
* Accidental Release Measures *
Spill Release Procedures:TREAT DUST AS FREE ASBESTOS. DO NOT DRY SWEEP
OR USE COMPRESSED AIR. WET METHOD SHOULD BE USED FOR EXTRACTION OF
DUST AND DEBRIS. HIGH EFFICIENCY PARTICULATE APPARATUS (HEPA)
VACUUMS SHOULD BE USED.
Neutralizing Agent:NOT APPLICABLE.
*Handling and Storage *
Handling and Storage Precautions:STORAGE- AVOID CREATING DUST BY
SANDING OR GRINDING THE PRODUCT.
Other Precautions:USE IN WELL VENTILATED AREA. AVOID BREATHING DUST OR
FIBERS. MINIMIZE CONTACT WITH SKIN. AVOID CONTACT WITH EYES. DO NOT
RAISE DUST. WASH THOROUGHLY AFTER HANDLING AND BEFORE EATING OR
DRINKING. KEEP AWAY FROM REACH OF CHILDREN.
* Physical/Chemical Properties *
HCC:T6
Spec Gravity:1.6 - 2.8
Solubility in Water:NO
Appearance and Odor:SOLID, LIGHT TAN TO DARK GREY COLOR, FRICTION
MATERIAL ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:FIRE AND CREATING DUST
Hazardous Decomposition Products:ASBESTOS FIBERS, CARBON MONOXIDE AND
CARBON DIOXIDE MAY BE RELEASED OR FORMED.
* Disposal Considerations *
Waste Disposal Methods:WASTE SHOULD BE CONTAINED IN IMPERMEABLE BAGS,
LABELED AND DISPOSED IN ACCORDANCE WITH ALL LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR APPROPRIATE NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:USE ONLY IN A CHEMICAL FUME HOOD.
Other Protective Equipment:OTHER PROTECTIVE CLOTHING, SAFETY SHOWER AND
EYE BATH.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
MATL TO AVOID: LIGHT SENSITIVE. FIRST AID PROC: PROVIDED PERSON IS
CONSCIOUS. CALL A PHYSICIAN. WASTE DISP METH: SCRUBBER. DISPOSE OF
IN ACCORDANCE WITH FEDERAL, STATE AND LOCAL REGULATIONS .
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:OXALYL BROMIDE
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: HARMFUL IF SWALLOWED, INHALED,
OR ABSORBED THRU SKIN. CAUSES BURNS. MATERIAL IS EXTREMELY
DESTRUCTIVE TO TISSUE OF MUCOUS MEMBRANES AND UPPER RESPIRATORY
TRACT, EYES & SKIN. INHALATION MAY BE F ATAL AS A RESULT OF SPASM,
INFLAMMATION& PULMONARY EDEMA. SYMPTOMS OF EXPOSURE MAY INCLUDE
BURNING (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: SENSATION, COUGHING, WHEEZING,
LARYNGITIS, SHORTNESS OF BREATH, HEADACHE, NAUSEA AND VOMITING.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
SEEK MED ADVICE. ASSURE ADEQ FLUSHING OF EYES BY SEPARATING LIDS
MIN WHIL E REMOVING CONTAMD CLTHG & SHOES. DISCARD CONTAMD CLTHG &
SHOES. INHAL: REMOVE TO FRESH AIR. IF NOT BRTHG GIVE ARTF RESP. IF
BRTHG IS DFCLT, GIVE OXYGEN. INGEST:WASH OUT MOUTH W/WATER (SUPP
DATA)
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL POWDER. DO NOT USE
WATER.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:WATER HYDROLYZES MATL LIBERATING ACIDIC
GAS WHICH IN CONT W/METAL SURF CAN GENERATE FLAMM &/OR EXPLOSIVE
HYDROGEN GAS. EMITS TOX FUMES UNDER FIRE CNDTNS.
* Accidental Release Measures *
Spill Release Procedures:EVAC AREA. WEAR NIOSH/MSHA APPRVD SCBA, RUBBER
IN COVERED CONTRS USING NON-SPARKING TOOLS & TRANSPORT OUTDOORS.
VENT AREA & WASH SPI LL SITE AFTER MATL PICKUP IS COMPLETE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:DO NOT BREATHE VAP. DO NOT GET IN
EYES, ON SKIN/CLTHG. AVOID PRLNGD/RPTD EXPOS. POISON. CORR.
LACHYRMATOR. KEEP TIGHTLY CLSD. STORE UNDER NITROGEN.
Other Precautions:LIGHT AND MOISTURE SENSITIVE. CAUSES BURNS.
REFERIGERATE. IF YOU FEEL UNWELL, SEEK MEDICAL ADVICE (SHOW THE
LABEL WHERE POSSIBLE).
* Physical/Chemical Properties *
Appearance and Odor:YELLOW LIQUID
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
BASES, OXIDIZING AGENTS, ALCOHOLS, CORRODES STEEL, DO NOT ALLOW WATER
TO ENTER CONTR BECAUSE OF VIOLENT RXN, (SUPP DATA)
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:TOXIC FUMES OF CARBON MONOXIDE, CARBON
DIOXIDE, HYDROGEN BROMIDE GAS.
* Disposal Considerations *
Waste Disposal Methods:MATL SHOULD BE IGNITED IN PRESENCE OF SODIUM
CARBONATE & SLAKED LIME (CALCIUM HYDROXIDE). SUBSTANCE SHOULD BE
MIXED W/VERMICULITE & THEN W/DRY CAUSTICS, WRAPPED IN PAPER &
BURNED IN A CHEM INCINERATOR EQUIPPED W/AN AFTERBURNER & (SUPP
DATA)
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:GENERALLY NOT NECESSARY
Ventilation:LOCAL EXHAUST: SATISFACTORY
Work Hygienic Practices:NORMAL HYGIENE PRACTICES
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:PROPANE
Ingred Name:BENZIN, NAPHTHA, MINERAL SPIRITS
Ingred Name:METHYLENE CHLORIDE(SARA III)
Other REC Limits:A2 CARCINOGEN
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: DIZZINESS, & NASAL
IRRITATION.
Explanation of Carcinogenicity:METHYLENE CHLORIDE IS CONSIDERED TO BE
AN A2 CARCINOGEN.
Effects of Overexposure:INHALATION: DIZZINESS, & NASAL IRRITATION.
* First Aid Measures *
First Aid:PROVIDE OXYGEN, OBTAIN MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point Method:TOC
Extinguishing Media:FOAM
* Accidental Release Measures *
Spill Release Procedures:CLEAN W/SAFETY SOLVENT
*Handling and Storage *
* Physical/Chemical Properties *
Appearance and Odor:LIGHT RED COLOR W/CHLORINATED SOLVENT ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:CO, CO2, HYDROGEN CHLORODE, PHOSGENE
* Disposal Considerations *
Waste Disposal Methods:APPROVED LANDFILL
| 1 | eyes_protection_mandatory |
Control Measures
*
Proprietary Ind: Y
*
Contractor Summary
*
*
Ingredients
*
-----------------------------
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: NO
Skin: NO
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: SINGLE EXPOSURE, SWALLOWING, SKIN ABSORPTION, INHALATION,
SKIN CONTACT, AND EYE CONTACT: NO EVIDENCE OF ADVERSE EFFECTS FOR AVAILABLE
INFORMATION. PROLONGED OR REPEATED EXPOSURES TO VAPORS GENERATED A T HIGH
TEMPERATURES MAY RESULT IN EYE AND RESPIRATORY TRACT IRRITATION AND IN THE
INHALATION OF (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: HLTH HAZ:HARMFUL AMOUNTS OF MATERIAL.
REPEATED CONTACT MAY CAUSE DERMATITIS IN A SMALL PROPORTION OF INDIVIDUALS.
Medical Cond Aggravated By Exposure: A KNOWLEDGE OF AVAILABLE TOXICOLOGY
INFORMATION AND THE PHYSICAL AND CHEMICAL PROPERTIES OF THE MATERIAL SUGGESTS
THAT OVEREXPOSURE IS UNLIKELY TO AGGRAVATE EXISTING MEDICAL CONDITIONS.
First Aid: INGESTION: NO HARMFUL EFFECTS EXPECTED. CALL MD IMMEDIATELY (FP N).
SKIN: WASH WITH SOAP AND WATER. INHALATION: REMOVE TO FRESH AIR. EYES: FLUSH
NO SPECIFIC ANTIDOTE. TREATMENT OF OVEREXPOSURE SHOULD BE DIRECTED AT THE
CONTROL OF SYMPTOMS AND THE CLINICAL CONDITION.
*
Handling and Disposal
*
Spill Release Procedures: WEAR SUITABLE PROTECTIVE EQUIPMENT. SMALL SPILLS CAN
BE FLUSHED WITH LARGE QUANTITIES OF WATER. LARGER SPILLS SHOULD BE COLLECTED
FOR DISPOSAL.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: INCINERATE IN A FURNACE WHERE PERMITTED UNDER
APPROPRIATE FEDERAL, STATE, AND LOCAL REGULATIONS.
Handling And Storage Precautions: NORM PRECS COMMON TO GOOD MFG PRACTICE SHOULD
BE FOLLOWED IN HANDLING & STORAGE. AVOID CONTACT W/EYES, SKIN &
CLOTHING. USE WITH ADEQUATE VENTILATION.
Other Precautions: NONE KNOWN.
*
Fire and Explosion Hazard Information
*
Flash Point Method: PMCC
Extinguishing Media: USE ALCOHOL-TYPE OR ALL-PURPOSE FOAM APPLIED BY
MANUFACTURER'S RECOMMENDED TECHNIQUES FOR LARGE FIRES. USE CARBON DIOXIDE OR
DRY CHEMICAL FOR SMALL FIRES.
Fire Fighting Procedures: USE NIOSH APPRVD SCBA & FULL PROT EQUIP (FP N).
DO NOT SPRAY A SOLID STREAM OF H*2O/FOAM DIRECTLY INTO A POOL OF HOT, BURNING
LIQ; THIS MAY CAUSE FROTHING.
Unusual Fire/Explosion Hazard: NONE.
*
*
Respiratory Protection: NONE EXPECTED TO BE NEEDED. NIOSH APPROVED RESPIRATOR
APPROPRIATE FOR EXPOSURE OF CONCERN (FP N).
Ventilation: GEN (MECH) ROOM VENT MAY BE ADEQ IF HANDLED AT AMBIENT TEMP/IN
COVERED EQUIP. IF AMBIENT TEMPS ARE EXCEEDED/OPERATIONS EXIST WHICH MAY
PRODUCE MISTING, (SUPDAT)
Other Protective Equipment: EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET ANSI
DESIGN CRITERIA (FP N).
Work Hygienic Practices: WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health: USERS OF "L" VERSION OF SHOULD CONSULT "LR"
VERSION FOR ADDITIONAL INFORMATION (FP N). VENTILATION: LOCAL EXHAUST
VENTILATION IS REQUIRED.
*
Physical/Chemical Properties
*
B.P. Text: DECOMPOSES
Vapor Density: <1
Evaporation Rate & Reference: NIL (BUTYL ACETATE = 1)
Solubility in Water: % BY WT. NIL
Appearance and Odor: CLEAR AMBER LIQUID WITH CHARACTERISTIC ODOR.
Percent Volatiles by Volume: NIL (WT)
*
Reactivity Data
*
Stability Indicator: NO
Stability Condition To Avoid: WARNING! DO NOT MIX THIS PRODUCT WITH NITRITES OR
OTHER NITROSATING AGENTS BECAUSE NITROSAMINES MAY BE FORMED. NITROSAMINES MAY
CAUSE CANCER.
Materials To Avoid: NORMALLY UNREACTIVE; HOWEVER, AVOID STRONG BASES AT HIGH
TEMPERATURES, STRONG ACIDS, STRONG OXIDIZING AGENTS & MATERIALS REACTIVE WITH
HYDROXYL GROUPS.
Hazardous Decomposition Products: COMBUSTION MAY PRODUCE OXIDES OF CARBON AND
NITROGEN. SEE "OTHER EFFECTS OF OVEREXPOSURE."
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
HAZCOM Label
*
Company Name: UNITED PARTS DIV
Label Required IND: Y
Status Code: C
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: COMBUSTIBLE. ACUTE: EXPOSURES TO VAPORS GENERATED AT
HIGH TEMPERATURES MAY RESULT IN EYE AND RESPIRATORY TRACT IRRITATION AND IN
THE INHALATION OF HARMFUL AMOUNTS OF MATERIAL. CHRONIC: REPEATED CONTAC T MAY
CAUSE DERMATITIS IN A SMALL PROPORTION OF INDIVIDUALS.
*
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED AIR-SUPPLIED MASK IN
CONFINED AREA OR IN EMERGENCY SITUATIONS.
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL AND/OR LOCAL
EXHAUST) VENTILATION TO MAINTAIN EXPOSURE BELOW TLV.
Other Protective Equipment:EYEWASH STATIONS, APRON.
Work Hygienic Practices:LAUNDER CONTAMINATED EQUIPMENT/CLOTHING BEFORE
RE-USE.
Supplemental Safety and Health
SPILL PROC: TOOLS. PREVENT PRODUCT FROM ENTERING WATER SUPPLY.
* Product Identification *
Preparer's Name:R. W. KLUG
CAGE:PENRA
CAGE:PENRA
* Composition/Information on Ingredients *
Ingred Name:SOLVENT NAPHTHA; (HEAVY AROMATIC NAPHTHA)
Fraction by Wt: 1-2%
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATES, HYDROTREATED (MILD)
HEAVY NAPHTHENIC DISTILLATE
Fraction by Wt: 7%+
ACGIH TLV:5 MG/M3 (MFR)
Ingred Name:MINERAL SPIRITS
Ingred Name:NAPHTHALENE
Fraction by Wt: 1-2%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYE AND SKIN IRRITATION.
RESPIRATORY IRRITATION POSSIBLE WITH EXCESSIVE INHALATION OF
VAPORS. CHRONIC: ASPIRATION OF PRODUCT INTO LUNGS CAN CAUSE
CHEMICAL PNEUMONITIS WHICH CAN BE FATAL. PROLON GED SKIN CONTACT
CAN CAUSE DRY SKIN ANDDEFATTING RESULTING IN IRRITATION AND
DERMATITIS.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:EYE: REDNESS, TEARING, PAIN, AND BLURRED
VISION. SKIN: REDNESS, DRY SKIN POSSIBLE WITH PROLONGED EXPOSURE.
INHAL: DIZZINESS, HEADACHE, NAUSEA. INGEST: NAUSEA, GI IRRITATION,
CRAMPS.
Medical Cond Aggravated by Exposure:PRE-EXISTING EYE, SKIN, AND
RESPIRATORY DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS
PRODUCT.
* First Aid Measures *
LIDS OCCASIONALLY. GET MD. SKIN: WASH WITH SOAP AND WATER. INHAL:
REMOVE TO FRESH AIR. RESTORE NORMAL BREATHING. GET MD. INGEST: GIVE
WATER TO CONSCIOUS VICTIM. CALL MD OR LOCAL POISON CONTROL CENTER
IMMEDIATELY FOR INSTRUCTIONS.
* Fire Fighting Measures *
Flash Point Method:TCC
Extinguishing Media:CO2, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR AND MAY
TRAVEL A GREAT DISTANCE TO AN IGNITION SOURCE AND FLASHBACK.
* Accidental Release Measures *
Spill Release Procedures:SM SPILL-CONTAIN & COLLECT PROD W/INERT
ABSORB.LRG SPILL-ELIM ALL IGNIT SOURCES.VENT AREA.PERSONS NOT
INVOLVED IN CLEAN-UP & NOT WEARING PROT EQUIP, SHOULD BE
EVAC.CONTAIN & COLLECT PROD W/ INERT ABSO RB & PLACE IN CLSD CNTNRS
W/NON-SPARK (SUPP DATA)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:STORE IN CLOSED CONTAINERS.
Other Precautions:EMPTY CONTAINERS MAY CONTAIN PRODUCT RESIDUES WHICH
MAY BE CONSIDERED HAZARDOUS. ALL PRECAUTIONS GIVEN IN THIS DATA
SHEET MUST BE OBSERVED.
* Physical/Chemical Properties *
HCC:F4
Vapor Pres:3-4
Vapor Density:>1
Solubility in Water:0
Appearance and Odor:CLEAR, AMBER LIQUID - PETROLEUM ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HIGH TEMPERATURES.
Hazardous Decomposition Products:CO, NOX.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE
AND FEDERAL REGULATIONS. IF PRODUCT BECOMES A WASTE, IT DOES NOT
MEET THE CRITERIA OF A HAZARDOUS WASTE AS DEFINED BY RCRA.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:SUFFICIENT ROOM VENTILATION
Ventilation:SUFFICIENT ROOM VENTILATION.
Other Protective Equipment:APRONS, EYEWASH STATION, EMERGENCY SHOWER
Work Hygienic Practices:WASH WITH SOAP AND WATER AFTER HANDLING PRODUCT
AND BEFORE EATING, DRINKING OR SMOKING.
Supplemental Safety and Health
THIS IS PART B OF TWO PART KIT. FOR PART A SEE PNI: E, SAME NSN. NOT
REGULATED PER MSDS.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:ALUMINUM SULFATE (SARA III)
Other REC Limits:NONE SPECIFIED
OSHA PEL:2 MG/M3
Ingred Name:SULFURIC ACID (SARA III)
Fraction by Wt: 3-5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1 MG/M3
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE SEVERE EYE IRRITATION AND
BURNS. MAY CAUSE SEVERE SKIN IRRITATION AND BURNS. INHALATION OF
MIST COULD CAUSE RESPIRATORY IRRITATION. INGESTION MAY CAUSE SEVERE
IRRITATION OF MUCUOUS MEMBRANES OR DIGESTIVE TRACT.
Explanation of Carcinogenicity:PRODUCT CONTAINS NO INGREDIENTS
CURRENTLY CLASSIFIED AS CARCINOGENIC BY NTP, IARC OR OSHA.
Effects of Overexposure:EYE IRRITATION. SKIN IRRITATION. RESPIRATORY
TRACT IRRITATION. MUCUOUS MEMBRANES IRRITATION. DIGESTIVE TRACT
IRRITATION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:IN CASE OF EYE CONTACT, IMMEDIATELY FLUSH WITH PLENTY OF
MINUTES. REMO VE CONTAMINATED CLOTHING. IN CASE OF INHALATION
OVEREXPOSURE, REMOVE TO FRESH AIR. IN CASE OF INGESTION, DRINK MILK
OR WATER, INDUCE VOMITING. OBTAIN IMMEDIATE MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point:NOT FLAMMABLE
Lower Limits:NONFLAMMABLE
Upper Limits:NONFLAMMABLE
Extinguishing Media:ANY EXTINGUISHING MEDIA APPLICABLE TO SURROUNDING
AREA.
Fire Fighting Procedures:EVACUATE PERSONNEL TO A SAFE AREA. KEEP
PERSONNEL REMOVED AND UPWIND OF FIRE. WEAR SELF-CONTAINED BREATHING
APPARATUS.
Unusual Fire/Explosion Hazard:WHEN HEATED TO DECOMPOSITION, EMISSION OF
TOXIC FUMES OF SULFUR DIOXIDE IS POSSIBLE.
* Accidental Release Measures *
Spill Release Procedures:USE APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT
DURING CLEANUP. DIKE SPILL. PREVENT LIQUID FROM ENTERING SEWERS,
WATERWAYS OR LOW AREAS. SOAK UP WITH SAND, OILDRY OR OTHER
ABSORBENT MATERIAL.
Neutralizing Agent:SPILL MAY BE NEUTRALIZED WITH POWDERED SODIUM
CARBONATE.
*Handling and Storage *
Handling and Storage Precautions:STORE IN WELL VENTILATED AREA. KEEP
CONTAINERS TIGHTLY CLOSED. DO NOT STORE WITH INCOMPATIBLE
MATERIALS.
Other Precautions:DO NOT STORE OR CONSUME FOOD, DRINK OR TOBACCO IN
AREA WHERE THEY MAY BECOME CONTAMINATED WITH THIS MATERIAL.
* Physical/Chemical Properties *
HCC:C1
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
pH:2.2
Evaporation Rate & Reference:NOT GIVEN
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR AND COLORLESS LIQUID, NO ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG ALKALIES, OXIDIZERS
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:OXIDES OF SULFUR.
* Disposal Considerations *
Waste Disposal Methods:RECOVER NONUSABLE FREE LIQUID AND/OR
CONTAMINATED WATER AND DISPOSE OF IN AN APPROVED AND PERMITTED
TREATMENT SYSTEM. REMOVE NONUSABLE SOLID MATERIAL AND/OR
CONTAMINATED SOIL FOR DISPOSAL IN AN APPROV ED AND PERMITTED
LANDFILL.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE REQUIRED WHEN USED AS INTENDED IN XEROX
EQUIPMENT. USE NIOSH APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE
OF CONCERN .
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER . FOR
USE OTHER THAN NORMAL CUSTOMER-OPERATING PROCEDURES (SUCH (ING 6)
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
MFR'S TRADE NAME/PART NO: BLACK DEVELOPER. EFTS OF OVEREXP: PRLNGD
PERIOD. THIS STUDY WAS CONDUCTED USING A SPECIAL TEST TONER TO
COMPLY W/EPA TESTING PROTOCOL. THE TEST TONER WAS TEN TIMES MORE
RESPI RABLE THAN COMMERCIALLY AVAILABLE XEROXTONER & WOULD NOT BE
FUNCTIONALLY SUITABLE FOR XEROX EQUIPMENT.
* Product Identification *
CAGE:0E6G9
CAGE:0E6G9
* Composition/Information on Ingredients *
Ingred Name:BARIUM, CALCIUM, MAGNESIUM, STRONTIUM, ALUMINUM SILICATE
FLUX; (CU-ZN FERRITE POWDER)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:POLYESTER
Fraction by Wt: >4.5%
OSHA PEL:N/K
ACGIH TLV:N/K
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3
Ingred Name:SPILL PROC: SHOULD BE USED TO REDUCE STATIC BUILDUP.
RESIDUE CAN BE REMOVED W/SOAP & COLD WATER. GARMENTS MAY BE (ING 5)
Ingred Name:ING 4: WASHED OR DRY CLEANED, AFTER REMOVAL OF LOOSE TONER.
Ingred Name:OTHER PROT EQUIP: AS IN BULK TONER PROCESSING FACILITIES),
ANSI APPRVD GOGGS & NIOSH APPRVD RESPS MAY BE REQD. (ING 7)
Ingred Name:ING 6: FOR MORE INFORMATION, CONTACT XEROX.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:MINIMAL RESPIRATORY TRACT IRRIT MAY
OCCUR AS W/EXPOS TO LARGE AMOUNTS OF ANY NON-TOXIC DUST. ADDNL
INFO: THE RSLTS OBTAINED FROM XEROX SPONSORED, CHRONIC TONER INHAL
STUDY, DEMONSTRATED NO LUNG CHANGEIN RATS FOR LOWEST (1MG/M3)
EXPOS LEVEL (IE, LEVEL MOST RELEVANT TO POTNTL HUMAN EXPOS). VERY
SLIGHT (EFTS OF OVEREXP)
OF ANIMALS AT MIDDLE (4MG/M3) EXPOS LEVEL, WHILE SLIGHT DEGREE OF
THESE FINDINGS ARE A TTRIBUTED TO "LUNG OVERLOADING," A GENERIC
RESPONSE TO EXCESSIVE AMOUNTS OF ANY DUST RETAINED IN LUNGS FOR
(SUPDAT)
Medical Cond Aggravated by Exposure:NONE WHEN USED AS DESCRIBED BY
PRODUCT LITERATURE.
* First Aid Measures *
WITH SOAP AND WATER. INHALATION: REMOVE FROM EXPOSURE. INGESTION:
DILUTE STOMACH CONTENTS WITH SEVERAL GLASSES OF WATER.
* Fire Fighting Measures *
Extinguishing Media:WATER, DRY CHEMICAL, CARBON DIOXIDE OR FOAM.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . AVOID INHALATION OF SMOKE.
Unusual Fire/Explosion Hazard:TONER IS A COMBUSTIBLE POWDER. LIKE MOST
ORGANIC MATERIALS IN POWDER FORM, IT CAN FORM EXPLOSIVE MIXTURES
WHEN DISPERSED IN AIR.
* Accidental Release Measures *
Spill Release Procedures:SWEEP UP OR VACUUM SPILLED TONER & CAREFULLY
TRANSFER INTO SEALABLE WASTE CNTNR. SWEEP SLOWLY TO MINIMIZE
GENERATION OF DUST DURING CLEAN-UP. IF VACUUM IS USED, THE MOTOR
MUST BE RATED AS DUST TIGHT. A CONDUCTIVE HOSE BONDED TO THE
MACHINE(ING 4)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:NONE.
Other Precautions:AVOID PROLONGED INHALATION OF EXCESSIVE DUST.
* Physical/Chemical Properties *
Appearance and Odor:BLACK POWDER; FAINT ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:PRODUCTS OF COMBUSTION MAY BE TOXIC.
AVOID BREATHING SMOKE.
* Disposal Considerations *
Waste Disposal Methods:THIS MATL IS NOT A HAZ WASTE ACCORDING TO
REQS HOWEVER, MAY BE MORE RESTRICTIVE. CONSULT APPROP FEDERAL,
STATE & LOCAL WASTE DISPOSAL AUTHORITIES. INCINERATE ONLY IN
CLOSEDCONTAINER.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:SCBA IF INVOLVED IN FIRE, OTHERWISE GAS MASK.
Ventilation:PROVIDE MECHAN(GEN/LOCAL EXHAUST)VENT TO MAINTN <TLV
Other Protective Equipment:EYE WASH STATION. APRONS. SPECIAL IMPERVIOUS
CLOTHING.
Supplemental Safety and Health
SOURCE OF DATA-EXAM OF STOCK IN WHSE. SAFETY & HEALTH DATA DEVELOPED BY
DGSC-STF.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:URANIUM
* Hazards Identification *
Effects of Overexposure:HAZ DEGREE DEPENDS ON TYPE/QUANT OF RADIATION.
LATENT EFFECTS:SOMATIC/GENETIC DAMAGE.
* First Aid Measures *
First Aid:USE FIRST AID. CALL MEDICAL EMERGENCY CARE. REMOVE/ISOLATE
COMTAMINATED CLOTHING.SHOWER VICTIM(S) W. SOAP & H*2O. DETAIN
PERSONNEL/EQUIPMENT EXPOSED. ADVISE MEDICAL PERSONNEL THAT
VICTIM(S) MAY BE CON TAMINATED.
* Fire Fighting Measures *
Extinguishing Media:EXTINQUISH W. AGENT SUITABLE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR CHEMICAL PROTECTIVE SUIT WITH SELF CONTD
BRTHG APP.
Unusual Fire/Explosion Hazard:SOME OF MATL MAY BURN. CONT MAY EXPLODE
IN HEAT OF FIRE.
* Accidental Release Measures *
*Handling and Storage *
Handling and Storage Precautions:SHIELD ACCORDING TO EMITTED RADIATION.
PROTECT FROM FILM/FILM PLATES. KEEP CONTAINERS CLOSED. STORE IN
AREA FOR RADIOACTIVE MATERIALS.
* Physical/Chemical Properties *
HCC:A2
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ISOLATE,SEGREGATE FROM MOST OTHER TYPE MATERIAL
Hazardous Decomposition Products:DEPENDS ON CHEMICAL COMPOSITION;
FISSION PRODUCTS
* Disposal Considerations *
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-IN ACCORDANCE WITH
DOD REGULATIONS AND FEDERAL,STATE & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE NEEDED.
Ventilation:PROVIDE LOCAL EXHAUST PREFERRED.
Other Protective Equipment:NONE
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:BUTYL BENZYL PHTHALATE (SARA III)
Fraction by Wt: <5%
Other REC Limits:5 MG/CUM
Ingred Name:OIL PETROLEUM DISTILLATES, SOLVENT-DEWAXED HEAVY PARAFFINIC
Other REC Limits:5 MG/CUM
ACGIH TLV:5 MG/CU.M (OIL MIST)
Ingred Name:CASTOR OIL
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE/SKIN: MELTED COMPOUND CAN CAUSE
SEVERE BURNS. INHALATION: DUE TO THE LOW PRESSURE AT AMBIENT
TEMPERATURES NO SIGNIFICANT NASAL/RESPIRATORY IRRITATION IS
EXPECTED. INGESTION: COMPARATIVELY NON-HAZA RDOUS AT ROOM
TEMERATURE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYE/SKIN: MELTED COMPOUND CAN CAUSE SEVERE
BURNS. INHALATION: NO SIGNIFICANT NASAL/RESPIRATORY IRRITATION IS
EXPECTED. INGESTION: COMPARATIVELY NON-HAZARDOUS AT ROOM
TEMPERATURE.
* First Aid Measures *
First Aid:EYE: FLUSH W/LARGE AMOUNTS OF WATER. GET MED ATT. SKIN: COOL
AT ONCE. IF 2ND OR 3RD DEGREE BURNS ARE SUSPECTED, GET MED ATT.
INHALATION: REMOVE TO FRESH AIR. INGESTION: SMALL AMOUNTS ARE
ESSENTIALLY H ARMLESS.
* Fire Fighting Measures *
Flash Point Method:COC
Extinguishing Media:WATER FOG, DRY CHEMICAL, FOAM & CO2
Fire Fighting Procedures:DON'T ENTER CONFINED SPACE W/O PROTECTIVE
EQUIP. THIS MAY INCLUDE SCBA TO PROTECT AGAINST HAZARDOUS EFFECTS
OF NORMAL PRODUCTS OF COMBUSTIO/OXYGEN DEFICIENCIES.
Unusual Fire/Explosion Hazard:WHEN HEATED >FLASH POINT, THIS MATERIAL
WILL RELEASE FLAMMABLE VAPORS WHICH CAN BURN/BE EXPLOSIVE IN
CONFINED SPACES/EXPOSED TO A SOURCE OF INGITION.
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION AROUND SPILL
AREA.
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL, DRY AREA.
Other Precautions:MELTED DIP SEAL WILL PRODUCE SEVERE BURNS IF ON BODY.
* Physical/Chemical Properties *
Vapor Pres:0.1
Spec Gravity:<1
Evaporation Rate & Reference:(BU AC = 1): <1
Solubility in Water:NEGLIGIBLE
Percent Volatiles by Volume:.1%
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS & ALKALIS
Stability Condition to Avoid:STRONG OXIDIZERS
Hazardous Decomposition Products:CO
Conditions to Avoid Polymerization:DIPPING TEMPERATURES IN EXCESS OF
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF CONTAMINATED MATERIAL IN AN APPROVED
DISPOSAL SITE, COMPLY W/FEDERAL, STATE & LOCAL REGULATIONS
CONCERNING WASTE DISPOSAL INTO LANDFILLS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:SCBA WHEN LARGE NUMBERS OF CELLS ARE INVOLVED IN
A FIRE.
Ventilation:SUBSEQUENT TO FIRE, PROVIDE AS MUCH VENTILATION AS
POSSIBLE.
Other Protective Equipment:NONE
Supplemental Safety and Health
MSDS INFORMATION IS FOR MANGANESE DIOXIDE.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:PAPER, SILICA GEL
Fraction by Wt: 1%
Other REC Limits:INORGANIC 0.1 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:PLASTIC
Fraction by Wt: 4%
Ingred Name:POTASSIUM HYDROXIDE
Fraction by Wt: 8%
Other REC Limits:2 MG/CUM (CEILING)
OSHA PEL:2 MG/CUM (CEILING)
ACGIH TLV:2 MG/CUM (CEILING)
OSHA PEL:5 MG/CUM
ACGIH TLV:5 MG/CUM
Ingred Name:ZINC
Ingred Name:WATER
Ingred Name:CARBON, ACTIVATED CARBON, GRAPHITE
Fraction by Wt: 4%
OSHA PEL:3.5 MG/CUM
ACGIH TLV:3.5 MG/CUM
Ingred Name:STEEL
Ingred Name:BRASS
Fraction by Wt: 2%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:THESE CHEMICALS ARE CONTAINED IN A
SEALED CAN. RISK OF EXPOSURE OCCURS ONLY IF BATTERY IS
MECHANICALLY, PHYSICALLY/ELECTRICALLY ABUSED. SKIN & EYE CONTACT
W/POTASSIUM HYDROXIDE MAY CAUSE CHEMICAL BURN S & PERMANENT EYE
INJURY.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:CHEMICAL BURNS.
* First Aid Measures *
First Aid:SKIN/EYES: IMMEDIATELY FLUSH W/COPIOUS AMOUNTS OF WATER FOR
* Fire Fighting Measures *
Fire Fighting Procedures:WEAR SCBA WHEN A LARGE NUMBER OF CELLS ARE
INVOLVED IN A FIRE.
Unusual Fire/Explosion Hazard:CELLS MAY RELEASE TOXIC ZINC FUMES WHEN
EXPOSED TO FIRE.
* Accidental Release Measures *
Spill Release Procedures:AVOID SKIN & EYE CONTACT.
*Handling and Storage *
Handling and Storage Precautions:STORE AT ROOM TEMP. AVOID SKIN & EYE
CONTACT. DON'T ATTEMPT TO RECHARGE. INSTALL CELLS IAW/EQUIPMENT
INSTRUCTIONS. DON'T DISPOSE OF IN FIRE.
Other Precautions:REPLACE ALL BATTERIES IN EQUIPMENT AT SAME TIME.
DON'T MIX BATTERY SYSTEMS SUCH AS ALKALINE & ZINC CARBON IN SAME
EQUIPMENT. DON'T CARRY BATTERIES LOOSE IN POCKET/BAG.
* Physical/Chemical Properties *
Spec Gravity:5
Solubility in Water:0%
Appearance and Odor:BLACK POWDER
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HEAT, DISASSEMBLY, RECHARGE,
MECHANICAL/PHYSICAL/ELECTRICAL ABUSE, HIGH TEMPS, FIRE.
Hazardous Decomposition Products:WHEN HEATED: HAZARDOUS FUMES OF ZINC &
CAUSTIC POTASSIUM HYDROXIDE.
* Disposal Considerations *
Waste Disposal Methods:SMALL QUANTITIES: DISPOSE OF W/HOUSEHOLD TRASH.
LARGE QUANTITIES: TREAT AS IF A HAZARDOUS WASTE. DON'T INCINERATE
SINCE CELLS MAY EXPLODE AT EXCESSIVE TEMPS. DISPOSE OF IAW/FEDERAL,
STATE & LOCAL REGU LATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE EOSHA APPROVED FOR PROTECTION AGAINST
ACTIONLEVEL.
Ventilation:CONTROL W/MECH DUST COLLECTION EQUIPMENT TO WITHIN TLV.
Other Protective Equipment:USE SPECIAL CLOTHING REQUIRED FOR EXPOSURE
TO ASBESTOS DUST
Supplemental Safety and Health
* Product Identification *
Product ID:FLAT TRANSITE
Preparer's Name:KNETH A ROBERTS.
* Composition/Information on Ingredients *
Ingred Name:ASBESTOS, CHRYSOTILE
OSHA PEL:0.2 FIBERS/CC
Ingred Name:PORTLAND CEMENT
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:UNKNOWN Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE:POSSIBLE SKIN OR EYES
IRRITATION;NO FURTHER DATA AVAILABLE. CHRONIC:AIRBORNE ASBESTOS
FIBERS MAY CAUSE CHRONIC PULMONARY DISEASE AND CANCER.PRODUCT IS
YEARS BEFORE IT BECOME APPARENT
Explanation of Carcinogenicity:PRODUCT IS A KNOWN HUMAN CARCINOGEN IF
INHALED AS AIRBORNE FIBERS.
Effects of Overexposure:EXPOSURE TO ASBESTOS FIBER CAN CAUSE CHRONIC
PULMONARY DISEASE & CANCER, A KNOWN CARCINOGEN.
Medical Cond Aggravated by Exposure:PRE-EXISTING CONDITIONS MAY BE
WORSEN.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. AVOID INHALATION OF TOBACCO
SMOKE. EYE CONTACT: FLUSH WITH COPIOUS QUANTITIES OF WATER. SKIN
CONTACT: WASH OR SHOWER THOROUGHLY USING SOAP & WARM WATER.
* Fire Fighting Measures *
Flash Point:NONFLAMMABLE
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
Spill Release Procedures:VACUUM W/ASBESTOS VACUUM TO CLEAN SPILLAGE &
DUST CREATED. IF SWEEPING IS NECESSARY,ET DOWN SPILLAGE. USE
APPROVED RESPIRATORY EQUIP WHEN REQUIRED.
*Handling and Storage *
Handling and Storage Precautions:STORE FLAT. SMOKING GREATLY INCREASES
THE CHANGE FOR ASBESTOS-RELATED LUNG DISEASE. IF YOU WORWITH
ASBESTOS, DON'T SMOKE.
Other Precautions:CUTTING, DRILLING OR OTHERWISE ABRAIDING WILL RELEASE
ASBESTOS FIBERS!
* Physical/Chemical Properties *
Spec Gravity:1.6
Solubility in Water:NEGLIGIBLE
Appearance and Odor:SOLID GRAY SHEET - NO ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:NONE
* Disposal Considerations *
Waste Disposal Methods:DISPOSE IN AN APPROVED LANDFILL TO COMPLY WITH
FEDERAL, STATE & LOCAL LAWS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:MASK FOR ORG.VAP.IS VENTIL IS INADEQUATE
Ventilation:LOCAL EXHAUST PREFERRED,MECHANICAL EXHAUST ACEPTABLE.
Other Protective Equipment:FULL PROTECTIVE CLOTHING,SAFETY SHOWER,EYE
WASH STATION
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:TOLUENE (SARA III)
Ingred Name:HEXANE (N-HEXANE)
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)
* Hazards Identification *
Effects of Overexposure:EYE:IRR;SKIN:IRR,DEFAT.DRY;INH:IRR.BREATHING
TRACT,HEAD,NAUSEA,NARCOSIS
* First Aid Measures *
First Aid:REMOVE TO FRESH AIR. GIVE CPR/OXYGEN IF NEED. SKIN:WASH WITH
QUIET.ING:SEEK MD.ATTN. !
* Fire Fighting Measures *
Lower Limits:1.2
Extinguishing Media:CO*2, FOAM, DRY CHEM.
CONTR.
Unusual Fire/Explosion Hazard:SOLVENTS ARE FLAMM;VAPORS ARE
EXPLOSIVE;CHLORIDE FUMES MAY BE LIBERATED IN A FIRE
* Accidental Release Measures *
Spill Release Procedures:VENTIL AREA.REMOV.IGN.SOURCES.TAKE UP SPILL
W.ABS.MTL.CLEAN UP RESIDUE W.TOLUENE.WEAR SOLV.RESIST.PROTECT.CLOTH
DISPOSAL CONTAINER.
*Handling and Storage *
Handling and Storage Precautions:STORE AT ROOM TEMP,AWAY FROM HEAT &
Other Precautions:USE W.ADEQUATE VENTIL.AVOID CONTACT W.SKIN & EYES.DO
NOT INHALE VAPORS.DO NOT TAKE INTERNALLY-FLAMMABLE-
* Physical/Chemical Properties *
HCC:F2
Vapor Pres:SUP
Vapor Density:>2
Evaporation Rate & Reference:>2 (BU AC=1)
Solubility in Water:INSOL
Appearance and Odor:TAN COLORED FLUID;SOLVENT ODOR?
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS
Stability Condition to Avoid:DANGEROUS WHEN EXPOSED TO HEAT AND FLAME
Hazardous Decomposition Products:CO,CO*2,CHLORIED FUMES
* Disposal Considerations *
Waste Disposal Methods:KEEP IN COVERED DRUMS,PENDING DISPOSAL. HANDLE &
DISPOSE IN FULL COMPLIANCE WITH ALL APPLICABLE
INTERNATIONAL,FEDERAL,STATE, & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Ventilation:MECH, REC
Other Protective Equipment:NONE
Supplemental Safety and Health
KEY1:D1
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:MANGANESE DIOXIDE (AS MANGANESE)
OSHA PEL:C,5 MG/M3/1 FUME TWA
ACGIH TLV:5 MG/M3 DUST/1 FUME
* Hazards Identification *
Effects of Overexposure:MAY CAUSE SKIN/EYE IRRIT UPON CNTCT
* First Aid Measures *
First Aid:WASH HANDS THOROUGHLY. FLUSH EYES W/WATER COPIOUSLY. GIVE
EMETIC IF INGESTED. CONSULT MD.
* Fire Fighting Measures *
Extinguishing Media:CARBON DIOXIDE, FOAM, DRY CHEM
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
Spill Release Procedures:CLEAN SPILLAGE W/RAGS OR SWEEPING CMPD &
SLVNTS, MFR REC.
*Handling and Storage *
Handling and Storage Precautions:WASH HANDS AFTER HANDLING. DO NOT
Other Precautions:NONE
* Physical/Chemical Properties *
HCC:F2
Spec Gravity:2
Appearance and Odor:BLACK PASTE, LITTLE ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
* Disposal Considerations *
Waste Disposal Methods:NORMAL NONHAZ TRASH DISPOSAL OR PREFERABLY BURN
WASTE, MFR REC.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE REQUIRED WHERE ADEQUATE VENTILATION
CONDITIONS EXIST. IF AIRBORNE CONCENTRATION IS HIGH, USE AN
APPROPRIATE NIOSH/MSHA APPROVED RESPIRATOR OR DUST MASK.
Ventilation:USE ADEQUATE GENERAL OR LOCAL EXHAUST VENTILATION TO KEEP
FUME OR DUST LEVELS AS LOW AS POSSIBLE.
Other Protective Equipment:UNIFORM.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:C.I. BASIC VIOLET; (METHYL VIOLET)
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: SKIN/EYES: CAUSES IRRITATION.
CHRONIC: NONE IDENTIFIED.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE IDENTIFIED.
* First Aid Measures *
First Aid:INGEST: CALL MD. IF SWALLOWED, IF CONSCIOUS, IMMEDIATELY
INDUCE VOMITING. INHAL: IF INHALED, REMOVE TO FRESH AIR. IF NOT
BREATHING, GIVE ARTFICIAL RESPIRATION. IF BREATHING IS DIFFICULT,
GIVE OXYGEN. SKIN: FLUSH SKIN WITH WATER. EYES: IMMEDIATELY FLUSH
* Fire Fighting Measures *
Flash Point Method:CC
Extinguishing Media:USE MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:DECOMPOSES AT MELTING POINT. PRODUCES
HYDROGEN CHLORIDE, OXIDES OF NITROGEN, CARBON MONOXIDE, CARBON
DIOXIDE.
* Accidental Release Measures *
Spill Release Procedures:WEAR SCBA AND FULL PROTECTIVE CLOTHING. WITH
CLEAN SHOVEL, CAREFULLY PLACE MATERIAL INTO CLEAN, DRY CONTAINER
AND COVER. REMOVE FROM AREA. FLUSH SPILL AREA WITH WATER.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED.
SUITABLE FOR ANY GENERAL CHEMICAL STORAGE AREA.
Other Precautions:
* Physical/Chemical Properties *
Appearance and Odor:GREEN CRYSTALS
Percent Volatiles by Volume:0
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT.
Hazardous Decomposition Products:HYDROGEN CHLORIDE, OXIDES OF NITROGEN,
CARBON MONOXIDE, CARBON DIOXIDE.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL ENVIRONMENTAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NOT NORMALLY REQUIRED.WEAR A NIOSH APPROVED
RESPIRATOR IF CONDITIONS WARRANT
Ventilation:GENERAL DILUTION VENTILATION
DUSTING IS LIKELY
Other Protective Equipment:APPROPRIATE PROTECTIVE CLOTHING. REMOVE
CONTAMINATED CLOTHING AND WASH BEFORE REUSE.
Supplemental Safety and Health
FOR MINERAL OIL MIST, A MATERIAL RELATED TO HYDROCARBON OIL MIST.
* Product Identification *
Preparer's Name:INDUSTRIAL HYGIENE
* Composition/Information on Ingredients *
Ingred Name:MINERAL OILS
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3
Ingred Name:HYDROCARBON OILS
Minumum % Wt:1.
Maxumum % Wt:5.
OSHA PEL:5 MG/M3
ACGIH TLV:5MG/M3
Ingred Name:KAOLIN
ACGIH TLV:2 MG/M3 RESP DUST
Ingred Name:SILICA-CRYSTALLINE
Minumum % Wt:.1
Maxumum % Wt:1.
OSHA PEL:0.1 MG/M3
ACGIH TLV:0.1 MG/M3
Ingred Name:CADMIUM
< Wt:0.
Ingred Name:ETHYL ACRYLATE
Ingred Name:LEAD
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES
Health Hazards Acute and Chronic:EYE: CONTACT WITH LIQUID WILL CAUSE
IRRITATION. SKIN: REPEATED CONTACT MAY CAUSE IRRITATION.
INHALATION: NOT ANTICIPATED ROUTE OF EXPOSURE. INGESTION: NOT
ANTICIPATED ROUTE OF EXPOSURE. SMALL AMOUNTS ARE NOT ANTICIPATED
TO BE HARMFUL. CHRONIC: WHEN PRODUCT IS IN FINAL FORM AND ABRADED
OR DISTURBED, DUSTING MAY OCCUR AND CRYSTALLINE SILICA MAY BE
RELEASES INTO THE AIR.
Explanation of Carcinogenicity:CRYSTALLINE SILICA
Effects of Overexposure:POSSIBLE CANCER HAZARD. LONG TERM OVEREXPOSURE
TO CRYSTALLINE SILICA MAY CAUSE PERMANMENT LUNG DAMAGE AND REDUCED
PULMONARY FUNCTION.
* First Aid Measures *
WATER. REMOVE CONTAMINATED CLOTHING AND WASH BEFORE REUSE.
INHALATION: REMOVE TO FRESH AIR. INGESTION: DO NOT INDUCE VOMITING.
GIVE ONE GLASS OR WATER OR MILK. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
* Fire Fighting Measures *
Flash Point:NON-FLAMMABLE
Extinguishing Media:NON-FLAMMABLE IN LIQUID STATE, USE DRY CHEMICAL,
CARBON DIOXIDE, WATER FOG ON DRIED PRODUCT
Fire Fighting Procedures:WEAR SELF CONTAINED BREATHING APPARATUS &
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:POSSIBILITY OF PRESSURE BUILD UP IN
CLOSED CONTAINERS WHEN HEATED. WATER SPRAY MAY BE USED TO COOL THE
CONTAINERS
* Accidental Release Measures *
Spill Release Procedures:DIKE IF NECESSARY, CONTAIN SPILL WITH INERT
ABSORBANT AND TRANSFER TO CONTAINERS FOR DISPOSAL. KEEP OUT OF
SEWERS, WATERSHED OR WATER SYSTEMS
*Handling and Storage *
Handling and Storage Precautions:WEAR APPROPRIATE PROTECTIVE EQUUIPMENT
WHEN WORKING WITH THIS PRODUCT. AVOID TEMPERATURE EXTREMES IN
STORAGE. CONSULT THE TECHNICAL DATA SHEET FOR SPECIFIC STORAGE
INSTRUCTIONS.
* Physical/Chemical Properties *
Appearance and Odor:TAN PASTE, NO ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:INCOMPLETE COMBUSTION CAN YIELD LOW
MOLECULAR WEIGHT HYDROCARBONS, CARBON MONOXIDE, NITROGEN COMPOUNDS,
SULFUR COMPOUNDS.
* Toxicological Information*
N,N,N-TRIBUTYL-, HYDROXIDE- NOT LI STED BY ACGIH, IARC, NIOSH, NTP
OR OSHA. WATER: NOT LISTER BY ACGIH, IARC, NIOSH, NTP OR OSHA.
EPIDEMIOLOGY: NO DATA AVAILABLE. TERATOGENICITY: NO DATA
AVAILABLE.REPRODUCTIVE EFFECTS: NO DATA AVAI LABLE.
NEUROTOXICITY: NO DATA AVAILABLE. MUTAGENICITY: NO DATA AVAILABLE.
OTHER STUDIES: NO DATA AVAILABLE.
* Ecological Information *
Ecological:ECOTOXICITY: NOT AVAILABLE.ENVIRONMENTAL FATE: NOT
AVAILABLE.PHYSICAL/CHEMICAL: NOT AVAILABLE. OTHER: NOT
AVAILABLE.
* Disposal Considerations *
Waste Disposal Methods:SOLIDIFY AND DISPOSE OF IN AN APPROVED LANDFILL.
DISPOSE OF IN ACCORDANCE W/LOCAL, STATE & FEDERAL REGULATIONS.
* MSDS Transport Information *
Transport Information:DOT PROPER SHIPPING NAME: ADHESIVES, NMFC, ITEM
* Regulatory Information *
SARA Title III Information:NONE
Federal Regulatory Information:TSCA - SECTION 8B - PRODUCT IS IN
COMPLIANCE WITH TSCA'S INVENTORY REQUIREMENTS
* Other Information *
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE A NIOSH/MSHA APPROVED ORGANIC VAPOR/DUST
RESPIRATOR.
Ventilation:LOCAL EXHAUST: CONTROL THE EMISSION OF AIR CONTAMINANTS.
GENERAL: ASSIST W/THE REDUCTION OF AIR CONTAMINANTS.
Other Protective Equipment:SAFETY SHOWERS & EYE WASH STATIONS
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. CLEAN HANDS W/SOAP & WATER AFTER EVERY USAGE.
Supplemental Safety and Health
VAPOR DENSITY 3.6.
* Product Identification *
Preparer's Name:S ABDUL RAZZAK
* Composition/Information on Ingredients *
Ingred Name:DIETHYLENE GLYCOL, MALEIC ANHYDRIDE, PHTHALIC ANHYDRIDE
Ingred Name:STYRENE, STYRENE MONOMER (SUSPECTED ANIMAL/HUMAN
Ingred Name:TALC (POWDER), (ASBESTOS FREE), TALCUM; HYDROUS MAGNESIUM
OSHA PEL:2 MG/CUM (RESP DUST)
ACGIH TLV:2 MG/CUM (RESP DUST)
Ingred Name:SODA LIME BOROSILICATE GLASS (AMORPHOUS SILICATE)
Ingred Name:TITANIUM DIOXIDE, TITANIUM OXIDE (SUSPECTED ANIMAL
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION. INHALATION: UPPER
RESPIRATORY IRRITATION. SKIN: IRRITATION & DERMATITIS. IF
ECZEMATOUS DEVELOPS, MOST OFTEN OCCURS ON THE BACK OF HANDS, WRISTS
& FOREARMS.
Explanation of Carcinogenicity:STYRENE IS A SUSPECTED 2B ANIMAL
CARCINOGEN BY IARC.
Effects of Overexposure:IRRITATION, DRUGGED, SLEEPY, UNCONSCIOUSNESS,
RASH.
Medical Cond Aggravated by Exposure:RESPIRATORY CONDITIONS SUCH AS
ASTHMA, CHRONIC BRONCHITIS, EMPHYSEMA.
* First Aid Measures *
First Aid:EYES: FLUSH W/PLENTY OF WATER. SKIN: WASH THOROUGHLY W/SOAP &
WATER. INHALATION: REMOVE TO FRESH AIR. GIVE CPR/OXYGEN IF NEEDED.
INGESTION: DON'T INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN ALL
CASES .
* Fire Fighting Measures *
Flash Point Method:TCC
Flash Point:(SEE SUPP)
Lower Limits:1.1
Upper Limits:6.1
Extinguishing Media:CO2, DRY CHEMICAL (SMALL FIRES), FOAM & WATER FOG
(LARGE FIRES).
Fire Fighting Procedures:VENT SMOKE & USE GAS MASK/REMOTE AIR SUPPLY.
WEAR A MSHA/NIOSH APPROVED SCBA W/PROTECTIVE EQUIPMENT.
Unusual Fire/Explosion Hazard:DENSE SMOKE SERIOUSLY LIMITS VISIBILITY.
* Accidental Release Measures *
Spill Release Procedures:REMOVE SOURCES OF IGNITION. INCREASE
VENTILATION TO MAXIMIZE VAPOR DISPERSAL. LARGE SPILL: DIKE TO
PREVENT RUNOFF INTO SEWERS/WATERWAYS. SHOVEL/WIPE. SWEEP/CLEAN
W/INERT MATERIAL SUCH AS SAND, VERMICU LITE & PLACE IN CLOSED
CONTAINER FOR DISPOSAL.
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL, DRY AREA. DON'T STORE
IN DIRECT SUNLIGHT. BOND/GROUND CONTAINERS FOR TRANSFER TO PREVENT
STATIC SPARKS. AVOID CONTACT W/SKIN & EYES.
Other Precautions:STYRENE VAPORS ARE UNINHIBITED & MAY CAUSE BLOCKAGE
OF VENTILATION VENTS DUE TO POLYMERIZATION. PERIODIC INSPECTION MAY
BE NECESSARY TO PREVENT BLOCKAGE. AVOID IMPROPER ADDITION OF
PROMOTERS & OXIDIZI NG AGENTS. AVOID ELECTRICAL EQUIPMENT.
* Physical/Chemical Properties *
Boiling Pt:B.P. Text:(SEE SUPP)
Vapor Density:(SEE SUPP)
Evaporation Rate & Reference:LESS THAN ETHER
Solubility in Water:NEGLIGIBLE
Appearance and Odor:WHITE PASTE W/STYRENE ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, PEROXIDES & OTHER OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME, DIRECT
SUNLIGHT/OTHER SOURCES OF IGNITION.
Hazardous Decomposition Products:CO, CO2, LOW MOLECULAR WEIGHT
HYDROCARBONS & ORGANIC ACIDS.
Conditions to Avoid Polymerization:UNREGULATED CONTACT W/ORGANIC
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF AS SOLID WASTE IAW/FEDERAL, STATE &
LOCAL REGULATIONS. IF DISCARDED, THIS MATERIAL & CONTAINERS ARE
CONSIDERED RCRA HAZARDOUS WASTES BASED ON THE CHARACTERISTIC OF
IGNITABILITY.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF AIRBORNE CONCENTRATION IS HIGH, USE AN
APPROPRIATE RESPIRATOR/DUST MASK.
Ventilation:ADEQUATE GENERAL/LOCAL EXHAUST VENTILATION.
Supplemental Safety and Health
* Product Identification *
Product ID:CYSTEINE HYDROCHLORIDE, DL-CYSTEINE
* Composition/Information on Ingredients *
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN: IRRITATION. MATERIAL IS
IRRITATING TO MUCOUS MEMBRANES & UPPER RESPIRATORY TRACT.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. GIVE CPR/OXYGEN IF NEEDED.
ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Extinguishing Media:WATER SPRAY, CO2, DRY CHEMICAL POWDER,
ALCOHOL/POLYMER FOAM.
Fire Fighting Procedures:WEAR PROPER PROTECTIVE CLOTHING & SCBA.
* Accidental Release Measures *
Spill Release Procedures:WEAR SUITABLE PROTECTIVE CLOTHING. CAREFULLY
SWEEP UP & PLACE IN BAG FOR REMOVAL. WASH SITE W/WATER.
*Handling and Storage *
Other Precautions:AVOID CONTACT W/SKIN & EYES.
* Physical/Chemical Properties *
Solubility in Water:COMPLETE
Appearance and Odor:WHITE CRYSTALLINE POWDER.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products:CO2, CO, SULFUR OXIDES, NITROGEN
OXIDES & HYDROGEN CHLORIDE GAS.
* Disposal Considerations *
Waste Disposal Methods:DISSOLVE/MIX THE CHEMICAL W/COMBUSTIBLE SOLVENT
& BURN IN A CHEMICAL INCINERATOR EQUIPPED W/AFTERBURNER & SCRUBBER.
DISPOSE OF IAW/FEDERAL, STATE & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:SUPPLIED AIR W/FULL FACEPIECE,HELMET OR HOOD
Ventilation:LOCAL EXHAUST
Other Protective Equipment:FULL CLOTHING TO PREVENT SKIN CONTACT
Supplemental Safety and Health
OVEREXPOS:CAN CAUSE FORMATION OF CYSTS.CAUSES STILLBIRTHS.IRRITATES
EYES,NOSE,THROAT.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:POLYCHLORINATED BIPHENYLS (PCBS) (SARA III)
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
* Hazards Identification *
Effects of Overexposure:ABSORBED THRU SKIN,LUNGS,INTESTINE.CAUSES
CANCER,LIVER,KIDNEY,STOMACH,EYE,HEARING DISORDER(SUP DATA)
* First Aid Measures *
First Aid:EYES:FLUSH W/WATER IMMED.SKIN:WASH W/SOAP IMMED.INHAL:REMOVE
TO FRESH AIR.GIVE ART.RESPIR. AS NEEDED.INGEST:GET MEDICAL
ATTN.GIVE LARGE QTY OF SALT WATER,INDUCE VOMITING,BUT DO NOT MAKE
UNCONSCIOUS PE RSON VOMIT.
* Accidental Release Measures *
Spill Release Procedures:USE ABSORBENT & DIKES TO PREVENT
RUNOFF.ISOLATE & NOTIFY PROPER AUTHORITIES.
*Handling and Storage *
Handling and Storage Precautions:STORAGE MUST FOLLOW RCRA REQUIREMENTS.
* Physical/Chemical Properties *
HCC:V1
Appearance and Odor:LIGHT STRAW COLORED LIQUID,AROMATIC ODOR.
* Stability and Reactivity Data *
STRONG OXIDIZERS
* Disposal Considerations *
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-GENERALLY HIGH
TEMPERATURE INCINERATION.ONLY APPROVED DISPOSAL OPERATOR PERMITTED.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR WITH ORGANIC
VAPOR CARTRIDGE IF VAPOR CONCENTRATIONS EXCEEDS PERMISSIBLE
EXPOSURE LIMIT.
Ventilation:PROVIDE SUFFICIENT MECHANICAL,GENERAL,LOCAL EXHAUST TO
Other Protective Equipment:IMPERVIOUS PROTECTIVE CLOTHING AND CHEMICAL
RESISTANT SAFETY SHOES TO MINIMIZE CONTACT. EMERGENCY SHOWER AND
EYEWASH FACILITY SHOULD BE PROVIDED IN ALL AREAS IN WHICH THIS
PRODUCT IS HANDLED.
Work Hygienic Practices:WASH CONTAMINATED CLOTHING WITH SOAP AND WATER
AND DRY BEFORE REUSE.
Supplemental Safety and Health
THIS PRODUCT CONTAINS LOW LEVELS OF BARIUM DINONYLNAPHTHALENE SULFONATE
(<5%), WHICH HAS PRODUCEDPOSITIVE SKIN SENSITIZATION.
* Product Identification *
DIV
CAGE:1MDA6
* Composition/Information on Ingredients *
Ingred Name:NAPHTHALENESULFONIC ACID, DINONYL- , BARIUM SALT
Minumum % Wt:1.
Maxumum % Wt:5.
Other REC Limits:TWA 0.5 MG/M3MFR
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: MAY CAUSE EYE IRRITATION. SKIN:
NO ACCUTE EFFECTS EXPECTED. INGESTION: THIS PRODUCT MAY CAUSE
GASTROINTESTINAL DISTRESS WITH SYMPTOMS OF NAUSEA, VOMITING,
DIARRHEA, AND ABDOMINAL PAIN. INHALA TION: INHALATION OF HIGH
CONCENTRATIONS OF MISTS MAY PRODUCE IRRITATION AND DAMAGE TO THE
RESPIRATORY TRACT.CHRONIC EFFECTS: A REVIEW OF THE LITERATURE
DOES NOT SHOW OBVIOUS LONG TERM HAZARD.
Explanation of Carcinogenicity:NO COMPONENT KNOWN TO BE PRESENT IN THIS
PRODUCT AT >0.1% IS PRESENTLY LISTED AS A CARCINOGEN BY IARC, NTP
OR OSHA.
Effects of Overexposure:INGESTION: IRRITATION, NAUSEA, VOMITING,
DIARRHEA, ABDOMINAL PAIN. INHALATION: IRRITATION AND DAMAGE TO
RESPIRATORY TRACT. SKIN AND EYE IRRITATION.
Medical Cond Aggravated by Exposure:NO DATA PROVIDED BY RESPONSIBLE
PARTY.
* First Aid Measures *
First Aid:CALL PHYSICIAN IF SYMPTOMS PERSIST. EYES: FLUSH WITH WATER
REMOVE CONTAMINATED CLOTHING. WASH CLOTHING BEFORE REUSE. USE SKIN
CREAM FOR DEFATTED AREAS. INGESTION: ASPIRATION HAZARD. DO NOT
INDUCE VOMITING. IF PERSON IS COMATOSE OR UNCONSCIOUS, PLACE ON
LEFT SIDE WITH HEAD DOWN. GET MEDICAL ATTENTION. IF POSSIBLE, DO
NOT LEAVE IN DIVIDUAL UNATTENDED. INHALATION: MOVE TO FRESH AIR.
PROVIDE ARTIFICIAL RESPIRATION, IF NEEDED. SKIN:WASH WITH SOAP &
WATER. REMOVE CONTAMINATED CLOTHES.
* Fire Fighting Measures *
Flash Point Method:COC
Autoignition Temp:Autoignition Temp Text:N/D
Lower Limits:N/D
Upper Limits:N/D
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:WATER OR FOAM MAY CAUSE FROTHING.USE WATER TO
KEEP FIRE EXPOSED CONTAINER COOL.WATER SPRAY MAY BE USED TO FLUSH
SPILLS AWAY FROM EXPOSURE. FOR FIRES IN ENCLOSED AREAS, FIGHTERS
MUST USE SELF-CONTAINED BREATHING APPARATUS. PREVENT RUN-OFF FROM
FIRE CONTROL/DILUTION FROM ENTERING STREAMS OR DRINKING WATER
SUPPLY.
Unusual Fire/Explosion Hazard:NONE KNOWN.
* Accidental Release Measures *
Spill Release Procedures:LARGE SPILLS:WEAR PROTECTIVE EQUIPMENT. STOP
SOURCE OF LEAK IF POSSIBLE. RECOVER FREE LIQUID. REMOVE SPILL
WITH INERT ABORBENT SUCH AS SAND, CLAY, EARTH. TRANSFER TO PROPER
CONTAINERS FOR DISPOSAL . FLUSH AREA WITH WATER. SMALL SPILLS:
NEUTRALIZE AND/OR SOAK UP SPILL WITH INERT ABSORBENT. STORE IN A
CLOSED CONTAINER AND DISPOSE OF PROPERLY.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:MAINTAIN AMBIENT TEMPERATURES. AVOID
PROLONGED/REPEATED BREATHING OF VAPORS, MISTS, FUMES. KEEP
CONTAINER TIGHTLY CLOSED. DO NOT STORE NEAR HEAT, FLAME, STRONG
OXIDANTS. MAINTAIN ADEQUATE VENTILATIO N.
Other Precautions:NO DATA PROVIDED BY RESPONSIBLE PARTY.
* Physical/Chemical Properties *
HCC:V5
Melt/Freeze Pt:M.P/F.P Text:NOT KNOWN
Vapor Pres:NEGLIGIBLE
Vapor Density:N/D
Viscosity:NOT AVAILABLE
Evaporation Rate & Reference:NEGLIGIBLE
Solubility in Water:<0.1%
Appearance and Odor:AMBER FLUID; MILD ODOR
Percent Volatiles by Volume:NEGLIGIBLE
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS, CAUSTIC OR ACIDIC SOLUTIONS.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:SMOKE, FUMES, CO, CO2; MINOR AMOUNTS
OF VARIOUS HYDROCARBONS.
* Toxicological Information*
Toxicological Information:EYE: MAY CAUSE EYE IRRITATION. SKIN: NO
ACCUTE EFFECTS EXPECTED. INGESTION: THIS PRODUCT MAY CAUSE
GASTROINTESTINAL DISTRESS WITH SYMPTOMS OF NAUSEA, VOMITING,
DIARRHEA, AND ABDOMINAL PAIN. INHALA TION: INHALATION OF HIGH
CONCENTRATIONS OF MISTS MAY PRODUCE IRRITATION AND DAMAGE TO THE
RESPIRATORY TRACT.CHRONIC EFFECTS: A REVIEW OF THE LITERATURE
DOES NOT SHOW OBVIOUS LONG TERM HAZARD. CARCIN OGENICITY: NO
COMPONENT KNOWN TO BE PRESENT IN THIS PRODUCT AT >0.1% IS PRESENTLY
LISTED AS A CARCINOGEN BY IARC, NTP OR OSHA.
* Ecological Information *
Ecological:NO SPECIFIC ECOLOGICAL DATA ARE AVAILABLE FOR THIS PRODUCT.
* Disposal Considerations *
Waste Disposal Methods:THIS PRODUCT AS PURCHASED DOES NOT FALL UNDER
CURRENT U.S. EPA RCRA DEFINITIONS OF HAZARDOUS WASTE. UNDER RCRA IT
IS THE GENERATOR'S RESPONSIBILITY TO DETERMINE THE STATUS OF THE
WAST AT THE TIME OF I TS DISPOSAL. DISPOSE OF IN ACCORDANCE WITH
LOCAL, STATE AND FEDERAL REGULATIONS. INCINERATION IS REC OMMENDED.
* MSDS Transport Information *
Transport Information:PROPER SHIPPING NAME: NOT REGULATED. HAZARD
CLASS: NOT REGULATED. IDENTIFICATION NUMBER: NOT REGULATED. PACKING
* Regulatory Information *
IMMEDIATE-YES; DELAYED-NO; FIRE-NO; REACTIVITY-NO; SUDDEN RELEASE
BARIUM COMPOUND, 1.1%.
HAZARDOUS SUBSTANCES (EHS): NO LISTED INGREDIENTS AS PRESENTLY ON
IS NOT LISTED IN THE TSCA INVENT ORY. THE INDIVIDUAL INGREDIENTS IN
THE PRODUCT ARE LISTED IN THE TSCA INVENTORY.
State Regulatory Information:NO DATA PROVIDED BY RESPONSIBLE PARTY.
* Other Information *
| 1 | eyes_protection_mandatory |
Control Measures
*
*
Contractor Summary
*
*
Ingredients
*
OSHA PEL: 5 MG MG/M3 CEILING
------------------------------
OSHA PEL: 2 PPM
ACGIH TLV: 2 PPM/4 STEL
------------------------------
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE:LIQUID MAY CAUSE BURNS TO SKIN AND EYES. INHALATION
OF VAPORS MAY CAUSE COUGHING AND DIFFICULTY BREATHING. INGESTION MAY CAUSE
NAUSEA, VOMITING AND LOSS OF CONSCIOUSNESS.
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: NONE IDENTIFIED.
First Aid: INHAL:REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTF RESP)
(FP N). CALL A PHYSICIAN!!! INGEST:DO NOT INDUCE VOMITING; IF CONSCIOUS GIVE
WATER, MILK/MILK OF MAGNESIA. EYES:IMMED FLUSH W/PLENTY O F WATER FOR @ LST
CONTAMD CLOTHING & SHOES. WASH CLOTHING BEFORE RE-USE.
*
Handling and Disposal
*
Spill Release Procedures: WEAR NIOSH APPRVD SCBA & FULL PROT CLTHG. STOP
LEAK IF CAN DO SO W/OUT RISK. USE WATER SPRAY TO REDUCE VPORS. TAKE UP WITH
SAND OR OTHER NON-COMBUSTIBLE ABSORBENT MATL & PLACE INTO CONTAINER FOR
LATER DISP. FLUSH SPILL AREA WITH WATER.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE IN ACCORDANCE WITH ALL APPLICABLE FEDERAL,
(CORROSIVE WASTE).
Handling And Storage Precautions: KEEP CONTAINER TIGHTLY CLOSED. STORE IN
CORROSION-PROOF AREA.
Other Precautions: NONE SPECIFIED BY MANUFACTURER.
*
Fire and Explosion Hazard Information
*
Extinguishing Media: USE APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N).
*
*
Respiratory Protection: NIOSH APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF
CONCERN (FP N).
Ventilation: LOCAL EXHAUST, VENT HOOD.
Other Protective Equipment: ANSI APPRVD EYE WASH & DELUGE SHOWER (FP N). LAB
COAT.
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: TRADE NAME/PART NO: UG/ML (4.0% W/V). EYE
PROT:& FULL LENGTH FACESHIELD (FP N).
*
Physical/Chemical Properties
*
Spec Gravity: 1 (H*2O=1)
Evaporation Rate & Reference: NOT KNOWN
Solubility in Water: COMPLETE
Appearance and Odor: CLEAR, COLORLESS SOLUTION WITH NO ODOR.
*
Reactivity Data
*
Stability Indicator: YES
Materials To Avoid: ORGANIC MATERIALS, STRONG REDUCING AGENTS.
Hazardous Decomposition Products: OXIDES OF NITROGEN, SPONTANEOUS DECOMP IN
DMF.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
HAZCOM Label
*
Company Name: INORGANIC VENTURES INC
Label Required IND: Y
Status Code: C
Origination Code: G
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE:LIQUID MAY CAUSE BURNS TO SKIN AND EYES.
INHALATION OF VAPORS MAY CAUSE COUGHING AND DIFFICULTY BREATHING. INGESTION
MAY CAUSE NAUSEA, VOMITING AND LOSS OF CONSCIOUSNESS. CHRONIC:NONE LISTED BY
MANUFACTURER.
*
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:ENGINEERING CNTRLS DONT MAINTAIN AIRBORNE CONCEN
BEL RECOMMENDED EXPO LIMITS APPROV RESP MUST BE WORN.RESP TYPE:ACID
GAS.IF RESP USED PROGRAM SHOULD BE INSTITUTED TO ASSURE COMPLIANCE
W/VENTI RATES.SUPPL LOC EXHAU VENTI,CLSD SYS,RESP PROT (SUPP)
Other Protective Equipment:EYEBATH, WASHING FACILITIES, SAFETY
SHOWER.PROTECTIVE CLOTHING APPROPRIATE FOR RISK OF EXPOSURE.
Work Hygienic Practices:WASH CONTAM CLOTH BEF REUSE;DESTROY/CLEAN WELL
CONTAM SHOES.WASH THOROUGHLY AFT HNDLG.
Supplemental Safety and Health
PH:1.2-1.3. VENTI:MAY BE NEEDED IN SPEC CIRCUMST(POOR VENTI SPACE,LG
SURF EVAPO,SPRAY,HEAT,ETC). 1STAID:ANYTHING BY MOUTH IF
UNCONSC.CALL DR/POIS CNTRL CNTR IMMED. OTHER PRECAUT:SOME
PLANTS,LOW POT TO BIOCONCEN.AFT DIL W/LG AMT OF H2O/2ND WASTE
TREAT-NOT EXPECTED TO CAUSE ADVERSE ENVIRO EFFECTS.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:WATER
Other REC Limits:NONE RECOMMENDED
Ingred
Name:4-(N-ETHYL-N-2-METHANESULFONYLAMINOETHYL)-2-METHYLPHENYLENEDIA
MINE
Other REC Limits:NONE RECOMMENDED
Ingred Name:LITHIUM SULFATE
Other REC Limits:NONE RECOMMENDED
Ingred Name:POTASSIUM SULFITE
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SO2 GAS MAY BE LIBERATED FRM
PROD.CONTAINS
4-(N-ETHYL-N-2-METHANESULFONYLAMINOETHYL)-2-METHYLPHENYLENEDIAMINE
SESQUISULFATE MONOHYDRATE.MAY CAUSE KID DMG BASED ON ANIMAL
DATA.LITHIUM SULFATE:TOXICOLOG ICAL PROPERTIES HAS NOT BEEN FULLY
INVESTIGATED,HNDLG/USE MAY PRESENT ADDN HAZ.MATL PHARMOCOLOGICALLY
ACTIVE (SIGN/SYMP)
Explanation of Carcinogenicity:PER MSDS:CARCINOGENICITY
CLASSIFICATION:IARC/ACGIH/NTP/OSHA:NONE.
Effects of Overexposure:HEALTH:CAN CAUSE ADVERSE EFFECTS ON
KID/CNS/CARDIOVASC & ENDOCRINE SYS/GI TRACT/BLOOD.INHAL:LIBERATES
SO2-IRRIT RESP TRACT.EYE:CAUSES IRRIT.SKIN:CAUSES IRRIT.MAY CAUSE
ALLERGIC SKIN RX.INGEST:HARMFUL. SOME ASTHAMTICS/SULFITE SENS
PEOPLE MAYEXPERIENCE WHEEZ,CHEST TIGHTNESS,STOMACH
UPSET,HIVES,FAINT,WEAK,DIARR.
Medical Cond Aggravated by Exposure:SOME ASTHMATICS OR HYPERSENS PEOPLE
MAY EXPERIENCE DIFFI IN BREATH.SOME ASTHMATICS OR SULFITE-SENS
PEOPLE MAY EXPERIENCE WHEEZING,CHEST TIGHTNESS,STOMACH
UPSET,HIVES,FAINATNESS,,WEAKNESS,DIARRHEA.
* First Aid Measures *
First Aid:INHAL:MOVE TO FRESH AIR.TREAT SYMPTOMAT.SYMPT PERSIST GET MED
ATTN.NOTE TO DR:STRONG ALKALIS BIND TISSUE PROTEIN.FOLLOWING
INITIAL FLUSH W/H 2O CONT IRRIGA W/SALINE.CONT TIL PH OF TEARS
CLOTH/SHOES.GET MED ATTN.INGEST:INDUCE VOMIT AS DIRE BY MED
PERSON.NEVER GIVE (SUPPLEMEN)
* Fire Fighting Measures *
Flash Point:NONE
Autoignition Temp:Autoignition Temp Text:NP
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL, ALCOHOL
FOAM.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATH APPARATUS/PROT
CLOTH.FIRE/EXCESSIVE HEAT MAY PRODUCE HAZ DECOMPOSITION PRODUCTS.
Unusual Fire/Explosion Hazard:NONE.
* Accidental Release Measures *
Spill Release Procedures:FLUSH TO SEWER W/LG AMTS OF WATER.MAY REQUIRE
INERT MATL.THEN PLACE IN CNTNR FOR CHEMICAL WASTE.CLEAN SURFACE
THOROUGHLY TO REMOVE RESIDU AL CONTAMINATION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:AVOID MIST/VAP BREATH @CONC >EXPO
LIMITS.DONT GET IN EYE/SKIN/CLOTH.USE W/ADEQU VENTI.KEEP FRM
OXIDIZ/INCOMPA MATLS.KEEP CNTNR TIGHTLY CLSD.
Other Precautions:STRONGLY ACIDIC AQU SOLN;PROPERTIES:LOW BIOCHEM OXY
DEMAND,LITTLE POT TO CAUSE OXY DEPLETION IN AQU SYS,HI POT TO
AFFECT AQU ORGANISMS,HI POT TO AFFECT 2ND WASTE TREAT MICROBIAL
METABOLISM,MOD POT TO AFFECT GERM &/OR EARLY GROWTH OF (SUPPL)
* Physical/Chemical Properties *
HCC:C1
Melt/Freeze Pt:M.P/F.P Text:NP
Decomp Temp:Decomp Text:NP
Vapor Density:0.6
pH:SUPPLE
Viscosity:NP
Evaporation Rate & Reference:NP
Solubility in Water:COMPLETE
Appearance and Odor:LIQUID, LIGHT AMBER COLOR, SHARP SULFUR DIOXIDE
ODOR
Corrosion Rate:NP
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
BASES, STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
OXIDES OF NITROGEN, OXIDES OF SULFUR.
* Disposal Considerations *
Waste Disposal Methods:DISCHARGE/TREATMENT/DISPOSAL MAY BE SUBJ TO
NATIONAL/STATE/LOCAL LAWS.FLUSH TO SEWER W/LG AMTS OF WATER.SINCE
EMPTY CNTNRS RETAINPROD RESIDUE FOLLOW LABEL WARNINGS EVEN AFT
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE NEEDED WITH ADEQUATE VENTILATION .USE
NIOSH/MSHA APPROVED RESPIRATOR IF NEEDED.
Ventilation:LOCAL/GENERAL TO MAINTAIN PEL/TLV.
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER,WORK
CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
AVOID PROLONGED OR REPEATED EXPOSURE. DO NOT GET ON SKIN OR IN EYES. DO
NOT BREATHE VAPORS OR MISTS.
* Product Identification *
Product ID:BIO-PEN P7F1;DYE PENETRANT-FLUORESCENT
Preparer's Name:SHEREE L.KINZEL
* Composition/Information on Ingredients *
Ingred Name:ALKYLOXYPOLYETHYLENOZY ETHANOL
Other REC Limits:NONE SPECIFIED
Ingred Name:OTHER COMPONENTS (TYPE NOT SPECIFIED)
Other REC Limits:NONE SPECIFIED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:IRRITATION OF
EYES,SKIN,RESPIRATORY OR G.I.TRACTS;CNS EFFFECTS LIKE HEADACHE
,NAUSEA, VOMITING ,DIARRHEA.CHRONIC:DRYING OF SKIN OR DERMATITIS.
Explanation of Carcinogenicity:DATA PER MSDS
Effects of Overexposure:MAY CAUSE IRRITATION OF EYES,SKIN,RESPIRATORY
OR G.I.TRACTS; INGESTION MAY CAUSE STOMACH UPSET. CNS EFFECTS LIKE
HEADACHE ,NAUSEA AND VOMITING.
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF AILMENTS
OR WITH A PRE-EXISTING DISEASE INVOLVING THE EYES, SKIN, OR
RESPIRATORY TRACT MAY BE AT INCREASED RISK FROM EXPOSURE.
* First Aid Measures *
First Aid:INHALATION:REMOVE TO FRESH AIR. RESUSCITATE IF NOT BREATHING.
GET MEDICAL ATTENTION. EYES:IMMEDIATELY FLUSH WITH PLENTY OF WATER
SKIN:REMOVE CONTAMINATED CLOTHING. WASH WITH SOAP AND WATER. IF
IRRITATION PERSISTS, GET MEDICAL ADVICE. INGESTION:DO NOT INDUCE
VOMITING. GIVE NOTHING BY MOUTH IF UNCONSCIOUS. GET IMMEDIATE
MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point Method:PMCC
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:NONE ANTICIPATED UNDER CONDITIONS OF
NORMAL USE.
* Accidental Release Measures *
Spill Release Procedures:USE PROPER PERSONAL PROTECTION;CONTAIN FREE
MATERIAL IF POSSIBLE;USE SUITABLE INERT ABSORBENT MATERIAL AND
RECOVER FOR PROPER DISPOSAL IN AN APPROVED CONTAINER.
Neutralizing Agent:NOT APPLICABLE.
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL, DRY, WELL VENTILATED
AREA. KEEP CONTAINERS TIGHTLY CLOSED WHEN NOT IN USE. DO NOT
EAT,DRINK OR SMOKE IN WORK AREA.
Other Precautions:DO NOT TAKE INTERNALLY. DO NOT BREATHE MIST. AVOID
PROLONGED OR REPEATED BREATHING OF VAPOR. AVOID CONTACT WITH EYES.
USE WITH ADEQUATE VENTILATION. WASH THOROUGHLY AFTER HANDLING.
* Physical/Chemical Properties *
HCC:N1
Vapor Pres:1
Vapor Density:>1.0
Evaporation Rate & Reference:0.1(N-BUTYL ACETATE=1)
Solubility in Water:SLIGHT
Appearance and Odor:FLUORESCENT YELLOW LIQUID ,MILD ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AND REDUCING AGENTS . STRONG ACIDS AND BASES.
Stability Condition to Avoid:HIGH TEMPERATURES , OPEN FLAMES,SPARKS AND
IGNITION SOURCES.
Hazardous Decomposition Products:CO AND CO*2
* Disposal Considerations *
Waste Disposal Methods:CONSULT LOCAL AUTHORITIES.DISPOSAL MUST BE MADE
IN ACCORDANCE WITH ALL APPLICABLE FEDERAL, STATE AND LOCAL LAWS AND
REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NORMALLY NOT NEEDED. NIOSH/MSHA APPROVED
RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:LOCAL EXHAUST:USED TO CAPTURE FUMES AND VAPORS.
Other Protective Equipment:OIL RESISTANT APRON.
Work Hygienic Practices:AVOID BREATHING OIL MIST. REMOVE OIL SOAKED
CLOTHING AND LAUNDER BEFORE REUSE. CLEANSE SKIN THOROUGHLY AFTER
CONTACT.
Supplemental Safety and Health
FIRST AID PROC:INGEST:CALL MD IMMEDIATELY. DO NOT INDUCE VOMITING. SPEC
* Product Identification *
Product ID:LUBRIPLATE HYDRAULIC OIL, HO-1
Preparer's Name:ROBERT J. SIBILIA
* Composition/Information on Ingredients *
Ingred Name:OIL MIST
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PROLONGED OR REPEATED SKIN CONTACT MAY
CAUSE SKIN IRRITATION. PRODUCT CONTACTING THE EYE MAY CAUSE
IRRITATION. HUMAN HEALTH RISKS MAY VARY FROM PERSON TO PERSON. AS A
PRECAUTION, EXPOSURE TO LIQUIDS, VAPORS, MISTS & FUMES SHOULD BE
MINIMIZED. THIS PRODUCT HAS A LOW ORDER OF ACUTE ORAL TOXICITY,
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:BUT MINUTE AMOUNTS ASPIRATED INTO THE
LUNGS DURING INGESTION MAY CAUSE MILD TO SEVERE PULMONARY INJURY.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
SUBSIDES. IF IRRIT PERSISTS, CALL MD. SKIN:REMOVE ANY CONTAM CLTHG
& WASH THORO W/SOAP & WARM WATER. INHAL:VAP PRESS IS VERY LOW &
INHAL AT ROO M TEMP IS NOT A PROBLEM. ID OVERCOME BYVAP FROM HOT
PROD MOVE FROM FRESH AIR IMMED & CALL MD. IF OVEREXPOSED TO OIL
MIST, REMOVE FROM FURTHER EXPOS UNTIL EXCESS OIL MIST CNDTN
SUBSIDES. (SUPP DATA)
* Fire Fighting Measures *
Flash Point Method:COC
Lower Limits:0.9%
Upper Limits:7%
Extinguishing Media:FOAM, DRY CHEMICAL, CARBON DIOXIDE OR WATER SPRAY
(FOG).
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . COOL EXPOSED CONTAINERS WITH WATER.
Unusual Fire/Explosion Hazard:DO NOT STORE OR MIX WITH STRONG OXIDANTS.
EMPTY CONTAINERS RETAIN RESIDUE. DO NOT CUT, DRILL, GRIND, OR WELD,
AS THEY MAY EXPLODE.
* Accidental Release Measures *
Spill Release Procedures:RECOVER LIQUID, WASH REMAINDER WITH SUITABLE
PETROLEUM SOLVENT OR ADD ABSORBENT. KEEP PETROLEUM PRODUCTS OUT OF
SEWERS AND WATER COURSES. ADVISE AUTHORITIES IF PRODUCT HAS ENTERED
OR MAY ENTER SEWERS AND WATER COURSES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINERS CLOSED WHEN NOT IN
USE. DO NOT HANDLE OR STORE NEAR HEAT, SPARKS, FLAME, STRONG
OXIDANTS.
Other Precautions:AVOID BREATHING OIL MIST. REMOVE OIL SOAKED CLOTHING
AND LAUNDER BEFORE REUSE. CLEANSE SKIN THOROUGHLY AFTER CONTACT.
* Physical/Chemical Properties *
Vapor Density:>5
Spec Gravity:SUPP DATA
Solubility in Water:NEGLIGIBLE
Appearance and Odor:TRANSPARENT AMBER LIQUID WITH MINERAL OIL ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NOT APPLICABLE.
Hazardous Decomposition Products:MAY FORM SULUR DIOXIDE. IF INCOMPLETE
COMBUSTION, CARBON MONOXIDE.
* Disposal Considerations *
Waste Disposal Methods:ASSURE CONFORMITY WITH APPLICABLE DISPOSAL
REGULATIONS. DISPOSE OF ABSORBED MATERIAL AT APPROVED WASTE
DISPOSAL FACILITY OR SITE.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NOT NORMALLY REQUIRED
Ventilation:GOOD ROOM VENTILATION USUALLY ADEQUATE FOR MOST OPERATIONS.
Other Protective Equipment:CLEAN BODY COVERING CLOTHING.
Work Hygienic Practices:MFR GAVE NO INFORMATION OF MSDS.
Supplemental Safety and Health
NONE
* Product Identification *
Product ID:SSR ULTRA COOLANT
* Composition/Information on Ingredients *
Ingred Name:MANUFACTURER CLAIMS ONLY NON-HAZARDOUS INGREDIENTS W/O
SPECIFYING ANY INDIVIDUAL INGREDIENT.
Other REC Limits: RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYE, SKIN, RESPIRATORY
TRACT. ACUTE-ESSENTIALLY NON-IRRITATING TO EYES OR SKIN. INHALATION
OF VAPORS:OIL MIST MAY CAUSE IRRITATION. INGESTION OF LARGE AMOUNTS
MAY CAUSE INJURY. ANIMALS E XPOSED TO EXCESSIVE AMOUNTS OF
POLYGLYCOLS SHOW SLIGHT KIDNEY & LIVER DAMAGE.
Explanation of Carcinogenicity:MANUFACTURER GAVE NO INFORMATION ABOUT
CARCINOGENICITY. HMIS FOUND NO LISTING & DOES NOT EXPECT IT TO BE
CARCINOGENIC.
Effects of Overexposure:IRRITATION, NAUSEA
Medical Cond Aggravated by Exposure:MFR GAVE NO INFORMATION OF MSDS.
* First Aid Measures *
First Aid:IF ANY IRRITATION PERSISTS OR SEVERE, GET MEDICAL ATTENTION.
INHALED:REMOVE FROM CONTAMINATED AREA. INGESTED:INDUCE VOMITING IF
LARGE AMOUNTS AR E INGESTED. MFR GAVE NO INFORMATION OF MSDS.
* Fire Fighting Measures *
Flash Point Method:COC
Extinguishing Media:USE WATER SPRAY, CARBON DIOXIDE (CO2), ALCOHOL FOAM
OR DRY CHEMICAL. USE WATER SPRAY TO COOL FIRE EXPOSED CONTAINERS.
Fire Fighting Procedures: - WEAR POSITIVE PRESSURE SELF-CONTAINED
BREATHING APPARATUS
Unusual Fire/Explosion Hazard:MFR GAVE NO INFORMATION OF MSDS.
* Accidental Release Measures *
Spill Release Procedures:SOAK UP W/INERT MATERIAL THEN SWEEP INTO
PLASTIC BAG FOR DISPOSAL.
Neutralizing Agent:MFR GAVE NO INFORMATION OF MSDS.
*Handling and Storage *
Handling and Storage Precautions:REASONABLE CARE SHOULD BE TAKEN IN
HANDLING THIS PRODUCT.
Other Precautions:
* Physical/Chemical Properties *
HCC:V6
NRC/State Lic Num:
Vapor Pres:< 1 MM
Appearance and Odor:LIGHT AMBER LIQUID - LOW ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIAL
Stability Condition to Avoid:STABLE UNDER NORMAL STORAGE CONDITIONS.
Hazardous Decomposition Products:BURINNG PRODUCES CARBON MONOXIDE,
CARBON DIOXIDE & WATER.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF I/A/W FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
Subsets and Splits