text
stringlengths 789
11.3k
| label
int64 0
1
| label_text
stringclasses 2
values |
|---|---|---|
* Exposure Controls/Personal Protection *
Respiratory Protection:NOT REQUIRED IF VENTILATION IS SUFFICIENT. USE
NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN
.
Ventilation:LOCAL EXHAUST VENTILATION IS RECOMMENDED. GENERAL
VENTILATION MAY BE ACCEPTABLE.
Other Protective Equipment:AS NEEDED TO PROTECT SKIN AND CLOTHING.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
CNDTNS (POLYM): BE BONDED. FAILURE TO OBSERVE CAUTIONS MAY RESULT IN
EXCESSIVE HEAT BUILD-UP WITH THE RELEASE OF TOXIC GASES.
* Product Identification *
Kit Part:Y
CAGE:ATTEL
CAGE:0PWA9
CAGE:ATTEL
* Composition/Information on Ingredients *
Ingred Name:PROPANE, 1-BUTOXY-2,3-EPOXY-; (N-BUTYL GLYCIDYL ETHER)
Ingred Name:SILICA GEL; (SILICA, AMORPHOUS)
OSHA PEL:6 MG/M3
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:IRRITATING TO SKIN AND EYES. CHRONIC
EXPOSURE MAY CAUSE SKIN SENSITIZATION. THE TOXICOLOGICAL PROPERTIES
OF THIS PRODUCT MAY NOT BE FULLY INVESTIGATED.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
MD. SKIN: FLUSH WITH PLENTY OF WATER. WASH SKIN THOROUGHLY WITH
SOAP & WATER, HAND CLEANER OR RUBBING ALCOHOL. DO NOT USE OTHER
SOLVENTS T O REMOVE MATERIAL FROM SKIN. IF IRRITATION PERSISTS SEE
MD. REMOVE CONTAMINATED CLOTHING & LAUNDER BEFORE REUSE. INHAL:
REMOVE TO FRESH AIR. INGEST: OBTAIN MEDICAL ATTENTION.
* Fire Fighting Measures *
Lower Limits:0.4%
Upper Limits:1.3%
Extinguishing Media:DRY CHEMICAL OR HALON FIRE EXTINGUISHER, WATER
SPRAY OR FOG AND FOAM.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:DENSE SMOKE AND TOXIC GASES MAY BE
PRODUCED UPON COMBUSTION.
* Accidental Release Measures *
Spill Release Procedures:SCRAPE UP AND TRANSFER TO METAL CONTAINER FOR
DISPOSAL. USE A RAG OR PAPER TOWEL WITH DETERGENT TO WIPE & CLEAN
OFF REMAINING RESIDUE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE. DO NOT MIX
IN BATCHES OF GREATER THAN ONE POUND TOTAL. FOLLOW RECOMMENDED
CURING PROCEDURES.
Other Precautions:SILICA PARTICLES IN THIS PRODUCT ARE IN WETTED
MATERIAL SO AIR-BORNE EXPOSURE WILL NOT OCCUR UNLESS CURED MATERIAL
IS SUBSEQUENTLY GROUND, MACHINED OR SANDED.
* Physical/Chemical Properties *
Vapor Pres:<2
Vapor Density:<1
Solubility in Water:<1%
Appearance and Odor:TRANSLUCENT, LIQUID WITH SWEET PLEASANT ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG LEWIS ACIDS OR MINERAL ACIDS.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
OXIDES OF NITROGEN, ALDEHYDES, ORGANIC ACIDS & UNDETERMINED
ORGANICS.
Conditions to Avoid Polymerization:AVOID MIXING RESIN & CURING AGENT IN
BATCHES GREATER THAN ONE LB TOTAL. DO NOT HEAT MATL UNLESS CURING
SURFS TO (SUPDAT)
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL RULES & REGULATIONS. APPROPRIATE DISPOSAL METHODS MAY
INCLUDE LANDFILL OR INCINERATION.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:THE APPROPRIATE NIOSH APPROVED RESPIRATORY
PROTECTION SHOULD BE USED IF AIRBORNE CHEMICAL CONCENTRATION
EXCEEDS THE EXPOSURE LIMITS (IF ANY) LISTED IN SECTION 8.
Ventilation:NOT NECESSARY IF ROOM IS WELL-VENTILATED.
Other Protective Equipment:EYEWASH AND DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA . WEAR LABORATORY COAT OR PROTECTIVE GARB WHEN
WORKING WITH MATERIAL.
Work Hygienic Practices:KEEP AWAY FROM FOODSTUFFS, BEVERAGES AND FEED.
WASH HANDS BEFORE BREAKS AND AT THE END OF WORK.
Supplemental Safety and Health
SPILL PROC: BINDERS, SAWDUST). WEAR PROTECTIVE EQUIPMENT. CLEAN AREA
WITH A DETERGENT. APPLY A SUITABLE DISINFECTANT. ADDITIONAL
INFORMATION: NO DANGEROUS SUBSTANCES ARE RELEASED.
* Product Identification *
Resp. Party Other MSDS Num.:L
* Composition/Information on Ingredients *
MG/KG
= Wt:1.3
Ingred Name:SODIUM AZIDE
= Wt:.1
Ingred Name:WATER
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: FOR BLOODBORNE PATHOGENS:
NON-INTACT SKIN, MUCOUS MEMBRANES, PARENTERAL CONTACT. PRIMARY
IRRITANT EFFECT: SKIN: NO IRRITANT EFFECT. EYE: NO IRRITANT EFFECT.
SENSITIZATION: NO SENSITIZING E FFECTS KNOWN. TARGET ORGANS/SYSTEM:
NOT APPLICABLE. SPECIAL HAZARDS: THIS PRODUCT CONTAINS HUMAN
SOURCED AND/OR POTENTIALLY INFECTIOUS COMPONENTS.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE EXPECTED.
* First Aid Measures *
First Aid:INHAL: REMOVE FROM SOURCE OF EXPOSURE. IF SIGNS OF TOXICITY
OCCUR, SEEK MEDICAL ATTENTION. PROVIDE SYMPTOMATIC/SUPPORTIVE CARE
AS NEEDED. SKIN: REMOVE FROM SOURCE OF EXPOSURE. WASH AFFECTED AREA
WITH SOAP AND WATER. SEEK MEDICAL ATTENTION AND APPROPRIATE
MINUTES. SEEK MEDICAL ATTENTION AND APPROPRIATE FOLLOW-UP.
INGESTION: RINSE M OUTH WITH WATER. SEEK MEDICAL ATTENTION AND
APPROPRIATE FOLLOW-UP. INFORMATION FOR DOCTOR: SEE SECTION 3:
SPECIAL HAZARDS. THE FOLLOWING SYMPTOMS MAY OCCUR: NONE EXPECTED.
* Fire Fighting Measures *
Extinguishing Media:CO*2, EXTINGUISHING POWDER OR WATER SPRAY. FIGHT
LARGER FIRES WITH WATER SPRAY OR ALCOHOL RESISTANT FOAM.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:PRODUCT DOES NOT PRESENT AN EXPLOSION
HAZARDS.
* Accidental Release Measures *
Spill Release Procedures:SAFE WORK PRACTICES: NIOSH APPRVD RESP PROT
SHOULD BE WORN IF EXPOS LIMITS CAN BE EXCEEDED. HANDLE AS
POTENTIALLY INFECTIOUS. MEASURES FOR ENVIRONMNETAL PROTECTION:
PREVENT LIQ & VAP FROM ENTERING INT O SEWAGE SYSTEM, WORKPITS &
CELLARS. CONTAIN SPILL W/APPROP ABSORB MATL. MEASURES FOR
CLEANING/COLLECTING: ABSORB W/LIQUID-BUILDING MATL (SAND,
DIATOMITE, ACID BINDERS, UNIVERSAL(SUPDAT)
*Handling and Storage *
Handling and Storage Precautions:INFO FOR SAFE HANDLING: HANDLE AS
POTENTIALLY INFECTIOUS MATL. INFO ABOUT PROT AGAINST EXPLOSIONS &
FIRES: NO SPECIAL MEASURES REQUIRED. STORAGE REQUIREMENTS TO BE MET
BY STOREROOMS & RECEPTACLES: NO SPECIAL REQUIREMENTS.
Other Precautions:INFO ABOUT STORAGE IN ONE COMMON STORAGE FACILITY: DO
NOT STORE TOGETHER W/ACIDS. FURTHER INFOMATION ABOUT STORAGE
CONDITIONS: PROTECT FROM HEAT & DIRECT SUNLIGHT: STORAGE CLASS: NOT
APPLICABLE. CLASS ACCORDING TO REGULATION ON FLAMMABLE LIQUIDS:
NOT APPLICABLE.
* Physical/Chemical Properties *
Melt/Freeze Pt:M.P/F.P Text:NOT DETERMINED
Solubility in Water:FULLY MISCIBLE
Appearance and Odor:COLORLESS LIQUID; ODORLESS.
* Stability and Reactivity Data *
REACTIONS WITH HEAVY METALS MAY FORM EXPLOSIVE SUBSTANCES. CONTACT WITH
ACIDS MAY RELEASE TOXIC GAS (I.E. HYDROGEN AZIDE HN*3).
Hazardous Decomposition Products:NO DANGEROUS DECOMPOSITION PRODUCTS
KNOWN.
* Toxicological Information*
(RAT).
* Ecological Information *
Ecological:GENERAL NOTES: DO NOT ALLOW UNDILUTED PRODUCT OR LARGE
QUANTITIES OF IT TO REACH GROUND WATER, WATER COURSE OR SEWAGE
SYSTEM.
* Disposal Considerations *
Waste Disposal Methods:PRODUCT RECOMMENDATION: & UNCLEANED PACKAGINGS:
RECOMMENDATION: DISPOSE IN ACCORDANCE WITH FEDERAL, STATE AND LOCAL
REGULATIONS. RECOMMENDED CLEANSING AGENT: WATER, IF NECESSARY WITH
CLEANSING AGENTS.
* MSDS Transport Information *
Transport Information:DOT REGULATIONS: HAZARD CLASS: REMARKS: NOT
REGULATED FOR TRANSPORTATION. LAND TRANSPORT ADR/RID (CROSS-BORDER)
ADR/RID CLASS: REMARKS: NOT REGULATED FOR TRANSPORTATION. IMDG
CLASS: MARINE POLLUTANT: NO. REMARKS: NOT REGULATED FOR
TRANSPORTATION. AIR TRANSPORT ICAO-TI AND IATA-DGR: ICAO/IATA
CLASS: REMARKS: NOT REGULATED FOR TRANSPORTATION.
* Regulatory Information *
SARA Title III Information:NATIONAL AND INTERNATIONAL REGULATIONS. SARA
Federal Regulatory Information:MARKINGS ACCORDING TO EUROPEAN
GUIDELINES: THE PRODUCT HAS BEEN CLASSIFIED & LABELLED I/A/
W/APPLICABLE EUROPEAN COMMUNITY (EC) DIRECTIVES. CODE LETTER &
HAZARD DESIGNATION OF PRODUCT: XN. HAZARD-DETE RMINING SUBSTANCE/S
INGESTED. SEEK MEDICA L ADVICE IMMEDIATELY & SHOW THIS
CONTAINER/LABEL. CLASSIFICATION/WARNING ACCORDING TO WORKSAFE
AUSTRALIA: HAZARDOUS.
KNOWN TO CAUSE CANCER: THE PRODUCT DOES NOT CONTAIN LISTED
SUBSTANCES. CHEMICALS KNOWN TO CAUSE REPRODUCTIVE TOXICITY: THE
PRODUCT DOES NOT CONTAIN LISTED SU BSTANCES.
* Other Information *
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF OVERHEATED, USE APPROPIATE NIOSH APPROVED
RESPIRATORY EQUIPMENT.
Ventilation:LOCAL AND MECHANICAL(GENERAL) EXHAUST VENTILATION IS
RECOMMENDED.
Other Protective Equipment:HAVE EMERGENCY EYE WASH AND SAFETY SHOWER
AVAILABLE.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING AND BEFORE
EATING, DRINKING OR SMOKING. LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
* Product Identification *
CAGE:0DHB8
* Composition/Information on Ingredients *
Ingred Name:NON HAZARDOUS INGREDIENT-PROPRIETARY MIXTURE
Other REC Limits:NONE SPECIFIED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:LOW ORAL AND DERMAL TOXICITY. MISTS OR
FUMES FROM EXCESSIVE HEATING MAY CAUSE EYE AND SKIN IRRITATION.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:MAY CAUSE NAUSEA, VOMITING, RESPIRATORY TRACT
IRRITATION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:CONTACT--WASH SKIN WITH SOAP AND WATER; FLUSH EYES WITH WATER
INHALE--REMOVE VICTIM TO FRESH AIR & GIVE CPR OR OXYGEN IF NEEDED.
INGEST--DO NOT IN DUCE VOMITING. CALL A PHYSICIAN.
* Fire Fighting Measures *
Flash Point Method:COC
Autoignition Temp:Autoignition Temp Text:UNKNON
Extinguishing Media:WATER FOG, CARBON DIOXIDE, FOAM, OR DRY CHEMICAL.
Fire Fighting Procedures:BURNING WILL PRODUCE FUMES. WEAR SELF
CONTAINED BREATHING APPARATUS & FULL TURN-OUT GEAR TO FIGHT FIRE.
AVOID SPREADING LIQUID AND FIRE BY WATER FLOODING.
Unusual Fire/Explosion Hazard:EXPOSURE TO HEAT BUILDS UP PRESSURE IN
CLOSED CONTAINERS. COOL WITH WATER SPRAY.
* Accidental Release Measures *
Spill Release Procedures:COVER WITH AN INERT, ABSORBENT MATERIAL &
REMOVE TO DISSPOSAL CONTAINER. OBEY ALL RELEVANT LOCAL, STATE AND
FEDERAL LAWS.
*Handling and Storage *
Handling and Storage Precautions:CAUTION--DO NOT USE OIL ABOVE MAXIMUM
& PAINT SURFACES.
Other Precautions:WIPE UP SPILLS IMMEDIATELY. AVOID EYE AND SKIN
CONTACT.
* Physical/Chemical Properties *
HCC:V6
Spec Gravity:<1
Evaporation Rate & Reference:SLOWER THAN BU/AC
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR LIQUID; MILD ODOR.
Percent Volatiles by Volume:NOT
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDANTS.
Hazardous Decomposition Products:BURNING WILL PRODUCE TOXIC FUMES.
* Disposal Considerations *
Waste Disposal Methods:OBEY RELEVANT FEDERAL, STATE AND LOCAL LAWS. DO
NOT CONTAMINATE ANY LAKES, STREAMS, PONDS OR UNDERGROUND WATER
SUPPLY.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH APPROVED RESPIRATOR IF VENTILATION IS
INADEQUATE.
Ventilation:PROVIDE LOCAL EXHAUST/MECHANICAL VENTILATION TO PROVIDE
ADEQUATE FRESH AIR & FOR ENCLOSED AREAS.
Other Protective Equipment:RUBBER APRON & BOOTS, EYE WASH STATION.
Supplemental Safety and Health
* Product Identification *
Product ID:SPEEDY-STRIP
* Composition/Information on Ingredients *
Ingred Name:METHYLENE CHLORIDE(SARA III)
Other REC Limits:A2 CARCINOGEN
Ingred Name:METHYL ALCOHOL (METHANOL) (SARA III)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: MAY CAUSE DIZZINESS,
UNCONSCIOUSNESS, LIVER & KIDNEY DAMAGE. EYES: PAIN & IRRITATION.
SKIN: IRRITATION & DERMATITIS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: DIZZINESS, UNCONSCIOUSNESS,
LIVER/KIDNEY DAMAGE. EYES: PAIN & IRRITATION. SKIN: IRRITATION &
DERMATIITS.
* First Aid Measures *
First Aid:SKIN: WASH W/HAND SOAP & WATER, APPLY MILD SKIN CREAM.
MED ATT. INHALATION: MOVE TO FRESH AIR, GIVE OXYGEN IF NEEDED. IF
UNCONSCIOUS, G IVE ARTIFICIAL RESPIRATION. NEVER GIVE FLUIDS/INDUCE
VOMITING IF PATIENT IS UNCONSCIOUS/HAVING CONVULSIONS. GET MED ATT.
* Fire Fighting Measures *
Flash Point:NOT FLAMMABLE
* Accidental Release Measures *
Spill Release Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS/AIR
SUPPLIED RESPIRATOR. EVACUATE THE AREA. MOVE UPWIND. DIKE AREA TO
CONTAIN SPILL. ABSORB W/ABSORBENT MATERIALS SUCH AS SAW
DUST/VERMICULITE & SHOVEL INTO APP ROPRIATE DISPOSAL CONTAINERS.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER CLOSED WHEN NOT IN USE.
STORE AT NORMAL ROOM TEMPERATURE. VAPORS ARE HEAVIER THAN AIR &
WILL COLLECT IN LOW AREAS.
Other Precautions:A SPILL/LEAK MAY CONTAMINATE UNDER GROUND WATER
SUPPLY. DON'T TRANSFER INTO UN-MARKED CONTAINERS.
* Physical/Chemical Properties *
Vapor Density:>AIR
Solubility in Water:SOLUBLE
Appearance and Odor:VISCOUS LIQUID. ORGANIC SOLVENT ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
DON'T MIX W/LIQUID OXYGEN/STRONG OXIDANTS.
* Disposal Considerations *
Waste Disposal Methods:DON'T FLUSH INTO SEWER. CONTAMINATED ABSORBENT
MATERIAL MUST BE DISPOSED OF IN AN APPROVED HAZARDOUS WASTE
FACILITY IN ACCORDANCE W/LOCAL, STATE & FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE SPECIFIED BY MANUFACTURER.
Ventilation:GOOD GENERAL WORKPLACE VENTILATION IS RECOMMENDED.
Other Protective Equipment:PROTECTIVE CLOTHING. DLA-HMIS: EYE WASH
STATION.
Work Hygienic Practices:WASH HANDS AFTER HANDLING AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health
PART 2 (CATALYST).
* Product Identification *
Kit Part:Y
Preparer's Name:DAVID HAAS
* Composition/Information on Ingredients *
Other REC Limits:NONE RECOMMENDED
Ingred Name:SILCONE RESIN
Other REC Limits:NONE RECOMMENDED
Ingred Name:MODIFIERS
Fraction by Wt: 1%
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: NO KNOWN HEALTH EFFECTS IF
VAPORS INHALED. CONTACT MAY CAUSE SKIN AND EYE IRRITATION. HARMFUL
IF SWALLOWED. CHRONIC: NO KNOWN HEALTH EFFECTS.
Explanation of Carcinogenicity:NO INGREDIENT OF A CONCENTRATION OF 0.1%
OR GREATER IS LISTED AS A CARCINOGEN OR SUSPECTED CARCINOGEN.
Effects of Overexposure:EYES-IRRITATION. SKIN-IRRITATION.
INGESTED-HARMFUL.
Medical Cond Aggravated by Exposure:NO DATA AVAILABLE FOR THIS PRODUCT
MIXTURE.
* First Aid Measures *
First Aid:GET MEDICAL ATTENTION IF SYMPTOMS PERSIST. EYES-FLUSH WITH
CONTAMINATED CLOTHES. WASH AFFECTED AREA WITH WATER. INGESTED-IF
CONSCIOUS & ALERT,DILUTE BY GIVING LARGE QUANTITIES OF WATER. GET
IMMEDIATE MEDICAL ATTENTION.
* Fire Fighting Measures *
Extinguishing Media:WATER FOG, CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:FIREFIGHTERS SHOULD WEAR SELF-CONTAINED
BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:TOXIC VAPORS EVOLVED UPON EXPOSURE TO
HEAT OR OPEN FLAME.
* Accidental Release Measures *
Spill Release Procedures:WIPE UP OR ABSORB WITH VERMICULITE OR OTHER
ABSORBENT MATERIAL. COLLECT WASTE IN SEALED CONTAINERS. SCRUB AREA
WITH SOAPY WATER & RINSE. PREVENT RINSES FROM ENTERING DRAINS OR
OTHER WATERWAYS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE. KEEP AWAY
FROM ANY HEAT OR OPEN FLAME. KEEP CONTAINER CLOSED WHEN NOT IN USE.
PROTECTIVE CLOTHING TO PREVENT EXPOSURE.
* Physical/Chemical Properties *
HCC:F4
Vapor Pres:NEGLIGIBLE
Solubility in Water:NEGLIGIBLE
Appearance and Odor:RED LIQUID.
Percent Volatiles by Volume:0
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:STORAGE IN OPEN CONTAINERS, EXPOSURE TO
HEAT AND/OR OPEN FLAME, UNCONTROLLED MIXING WITH INCOMPATIBLE
SUBSTANCES.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
SILICON DIOXIDE.
Conditions to Avoid Polymerization:HAZARDOUS POLYMERIZATION WILL NOT
OCCUR.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL ENVIRONMENTAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE SHOULD BE NEEDED.
USED. VENTILATION RATES SHOULD BE MATCHED TO CONDTIONS.
Other Protective Equipment:WEAR IMPERVIOUS PROTECTIVE CLOTHING
APPROPRIATE FOR RISK OF EXPOSURE. EYEBATH, SAFETY SHOWER, WASHING
FACILITIES.
Work Hygienic Practices:WASH THOROUGHLY AFT HANDLING.GOOD INDUSTRIAL
HYGIENE PRACTICE SHOULD BE FOLLOWED.
Supplemental Safety and Health
METABOLISM,MOD POT TO AFFECT GERMINATION &/OR EARLY FROWTH OF SOME
PLANTS.AFT DIL W/LG AMT OF WATER FOLLOWED BY 2ND WASTE TREATMENT
MATL NOT EXPECTED TO CAUSE ADVERSE EVNIRON EFFECTS. SEE SAME NSN
PNI ND:W(WORKING SOLN),3-PART W/OWN CAT#'S & NSN'S-SEE
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:WATER
Other REC Limits:NONE RECOMMENDED
Ingred Name:TRIETHANOLAMINE
Other REC Limits:NONE RECOMMENDED
Ingred Name:DIETHYLHYDROXYLAMINE
Other REC Limits:NONE RECOMMENDED
Ingred Name:SUBSTITUTED STILBINE (STILBENE SULFONIC ACID DERIVATIVE)
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM CHLORIDE
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL:EXPECTED TO BE A LOW HAZARD FOR
RECOMMENDED HANDLING. EYE:NO SPECIFIC HAZARD KNOWN. MAY CAUSE
TRANSIENT IRRIT. SKIN:CAUSES IRRITATION. INGEST:EXPECTED TO BE A
LOW INGEST HAZARD.
Explanation of Carcinogenicity:PER MSDS:CARCINOGENICITY
CLASSIFICATION:IARC/NTP/OSHA/ACGIH:NONE.
Effects of Overexposure:TRANSIENT EYE IRRITATION. SKIN IRRITATION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MFG.
* First Aid Measures *
First Aid:INHAL:MOVE TO FRESH AIR. TREAT SYMPTOMATICALLY. GET MED ATTN
IF SYMPTOMS PERSIST. EYE:WASH OUT IMMED W/WATER. GET MED ATTN IF
SYMPTOMS OCCUR. SKIN:WASH W/SOAP & WATER. GET MED ATTN IF SYMPTOMS
OCCUR. INGEST:DRINK 1-2 GLASSES OF WATER. SEEKMED ATTN.
* Fire Fighting Measures *
Extinguishing Media:CLASSIFIED AS COMBUSTIBLE. WATER SPRAY, CARBON
DIOXIDE, DRY CHEMICAL, ALCOHOL FOAM.
Fire Fighting Procedures:USE WATERSPRAY TO KEEP FIRE-EXPO CNTNRS
COOL.WEAR SELF-CONTAINED BREATHING APPARATUS & PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:FIRE/EXCESSIVE HEAT MAY PRODUCE HAZ
DECOMPOSITION PRODUCTS.MATL CONTAINS COMBUSTIBLE SOLVENT THAT MAY
ACCUMULATE IN CNTNR HEADSPACE.ELEVA TEMP CAN CAUSE DECOMP.
* Accidental Release Measures *
Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES. FLUSH TO SEWER
W/LG AMTS OF WATER.
Neutralizing Agent:NONE SPECIFIED BY MFG.
*Handling and Storage *
Handling and Storage Precautions:USE W/ADEQUATE VENTILATION. KEEP FROM
CONTACT W/OXIDIZING MATERIALS. KEEP AWAY FROM HEAT & FLAME. KEEP
CONTAINER CLOSED. STORE IN COOL PLACE.
Other Precautions:HEAT SENSITIVE-CAN DECOMPOSE IF HEATED.COMBUST
LIQ/VAP.KEEP OUT OF REACH OF CHILDREN.DO NOT HANDLE/USE TIL SAF
PRECAUTIONS IN MSDS HAVE BEEN READ/UNDERSTOOD.CNTNRS >1GAL LIQ/5LBS
SOLID:EMPTIED CNTNRS RETAIN PROD RESIDUE FOLLOW LOW WARNINGS.
* Physical/Chemical Properties *
HCC:F4
Vapor Density:0.6
Solubility in Water:COMPLETE
Appearance and Odor:LIQUID, YELLOW, STRONG AMINE ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products:OXIDES OF NITROGEN, CARBON MONOXIDE
AND CARBON DIOXIDE
* Disposal Considerations *
Waste Disposal Methods:DISCHARGE/TREAT/DISPOSAL MAY BE SUBJ TO
NAT/STATE/LOC LAWS.FLUSH TO SEWER W/LG AMTS OF WATER.MOD ALKALINE
AQU SOLN.LOW BIOCHEM OXY DEMAND;LITTLE POT TO CAUSE OXY DEPLETION
IN AQU SYS,LOW POT TO AFFECT AQU ORGANISMS,2ND WASTE TREAT MICRO
(SUPPLE)
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF VENT INADEQUATE, USE APPROVED RESPIRATORY
PROTECTION.
Ventilation:YES
Other Protective Equipment:PROTECTIVE CLOTHING.
Supplemental Safety and Health
MORE IFORMATION ON FILE.
* Product Identification *
CAGE:0AHD1
CAGE:0AHD1
* Composition/Information on Ingredients *
Ingred Name:KEROSENE
Other REC Limits:NONE RECOMMENDED
Ingred Name:ASPHALT (PETROLEUM)
Other REC Limits:NONE RECOMMENDED
ACGIH TLV:5 MG/M3
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: MINOR IRRIT. SKIN: MINOR IRRIT.
INHAL: CNS EFFECTS (HEADACHE, DIZZINESS, LOSS OF APPETITE,
WEAKNESS, LOSS OF COORDINATION). CHRONIC: REPEATED SKIN CONTACT MAY
BE HARMFUL.
* First Aid Measures *
WORN. SKIN: REMOVE CONTAM CLOTHES, WASH BEFORE REUSE, WASH
W/SOAP/WATER. VEGETABLE/MINERAL OIL MAY BE USED. INHAL: GET FRESH
AIR, SEE DR. IN GEST: GIVE WATER/MILK, GET MED AID, DONT INDUCE
VOMIT UNLESS ADVISED BY DR.
* Fire Fighting Measures *
Flash Point Method:TOC
Extinguishing Media:CO2, DRY CHEMICAL, FOAM, WATER FOG.
Fire Fighting Procedures:DO NOT ENTER ANY ENCLOSED/CONFINED FIRE SPACE
W/OUT PROPER PROTECTIVE EQUIPMENT INCLUDING SCBA.
Unusual Fire/Explosion Hazard:MAY EXPLODE, VAPOR SPREADS EASILY, MAY
* Accidental Release Measures *
Spill Release Procedures:KEEP AWAY FROM WATER, ELIMINATE IGNIT SOURCES,
ABSORB OR PUMP, REMOVE CONTAM SOIL, REPORT/RESPOND TO LG RELEASES
OR SPILLS PROPERLY.
*Handling and Storage *
Handling and Storage Precautions:NO IGNITS, GOOD VENT, KEEP CONTNR
CLSD, EMPTY CONTNR STILL HAZARDOUS, DONT USE PRESSURE TO EMPTY DRUM
OR EXPLOSION MAY RESULT.
* Physical/Chemical Properties *
Vapor Pres:2.0
Solubility in Water:SOLUBLE.
Appearance and Odor:BLACK LIQUID, W/KEROSENE ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS. (CHLORATES, NITRATES, & PEROXIDES).
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE, WATER
VAPOR, OXIDES OF SULFUR.
* Disposal Considerations *
Waste Disposal Methods:PLACE IN CONTAINER & DISPOSE IN ACCORDANCE
W/LOCAL, ENVIRONMENTAL OR HEALTH AUTHORITIES.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPRVD RESP PROT FOR PARTICULAR EXP
OF CONCERN
Ventilation:MECH ACCEPTABLE
Other Protective Equipment:SAFETY SHOWER & EYE BATH
Supplemental Safety and Health
WATER.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:TOLUENE (SARA III)
Fraction by Wt: 5%
Ingred Name:RUBBER, SYNTHETIC
Fraction by Wt: 7%
Ingred Name:RESIN, SYNTHETIC
Ingred Name:PETROLEUM OIL
Fraction by Wt: 5%
Ingred Name:SOAP
Fraction by Wt: 5%
* Hazards Identification *
Effects of Overexposure:NARCOTIC. SYMPTMS SUCH AS HDACHE, DROWSINESS,
INCOORD. AVOID EYE & PROLONGED SKIN CNTCT.
* First Aid Measures *
First Aid:INH: MOVE TO FRESH AIR. CALL MD IF NEC. SKIN: WASH THOROUGHLY
MD.
* Fire Fighting Measures *
Extinguishing Media:CO*2, DRY CHEM POWDER
Fire Fighting Procedures:SAME AS FOR ANY COMBUSTIBLE LIQ FIRE HAZ
Unusual Fire/Explosion Hazard:THIS ADHESIVE IS CLASSIFIED AS OSHA CLASS
III-A, COMBUSTIBLE LIQ, ACCORDING TO MFR.
* Accidental Release Measures *
Spill Release Procedures:ELIMINATE ALL SOURCES OF IGNITION &
FLAMMABLES. FLUSH & DILUTE W/PLENTY WATER.
*Handling and Storage *
Handling and Storage Precautions:KEEP FROM FREEZING. STORE BETWEEN
MFR.
* Physical/Chemical Properties *
Solubility in Water:APPRECIABLE
Appearance and Odor:TAN, LIGHT BODIED PASTE, AROMATIC RESIN TYPE ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE
Hazardous Decomposition Products:CO, CO*2
* Disposal Considerations *
Waste Disposal Methods:MFR SUGGESTS LANDFILL. DISPOSE IAW LOCAL, STATE,
FED REG.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:SODIUM HYDROXIDE (SARA III)
Fraction by Wt: <2%
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3, C
Ingred Name:BORIC ACID, DISODIUM SALT; (BORATE, TETRA, SODIUM SALT)
Fraction by Wt: <9%
OSHA PEL:N/K
ACGIH TLV:1 MG/M3 (MFR)
Ingred Name:NITROUS ACID, SODIUM SALT; (SODIUM NITRITE) (SARA III)
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL:IRRITATING TO RESPIRATORY TRACT.
SKIN CONTACT:MILDLY IRRITATING. EYE CONTACT:IRRITATING. PROLONGED
CONTACT MAY PRODUCE SEVERE DAMAGE TO DELICATE EYE TISSUE.
INGEST:IRRITATING TO GASTROINTESTINAL TRACT. MAY CAUSE NAUSEA &
VOMITING.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INHAL:REMOVE VICTIM TO FRESH AIR. IF SYMPTOMS PERSIST,
CONSULT MD. SKIN:FLUSH AFFECTED AREA W/PLENTY OF WATER. IF
IRRITATION DEVELOPS, CONSULT MD. EYES:FLUSH AT ONCE W/PLENTY OF
MEDICAL ATTENTION IMMEDIATELY. GIVE LARGE QUANTITIES OF WATER TO
DILUTE. NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
* Fire Fighting Measures *
Extinguishing Media:WATER, CARBON DIOXIDE, CHEMICAL FOAM.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:CONTACT W/STRONG ACIDS OR THERMAL
DECOMPOSITION MAY PRODUCE TOXIC FUMES.
* Accidental Release Measures *
Spill Release Procedures:FLUSH MATERIAL TO SEWER WHICH LEADS TO A
SUITABLE WASTE TREATMENT FACILITY.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER CLOSED. KEEP OUT OF
REACH OF CHILDREN. STORE IN A COOL, DRY PLACE.
Other Precautions:FOR INDUSTRIAL USE ONLY.
* Physical/Chemical Properties *
HCC:B3
Vapor Density:>1
pH:SUPDAT
Solubility in Water:COMPLETE
Appearance and Odor:BLUE LIQUID; SLIGHT THIAZOLE ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, STRONG OXIDIZERS, EXTREME HEAT.
Hazardous Decomposition Products:OXIDES OF CARBON, NITROGEN & SULFUR.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF I/A/W FEDERAL, STATE & LOCAL
GUIDELINES.
| 1 | eyes_protection_mandatory |
Control Measures
*
*
Contractor Summary
*
*
Ingredients
*
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
------------------------------
------------------------------
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
------------------------------
% Wt: 2-3
------------------------------
------------------------------
EPA Rpt Qty: 1 LB
DOT Rpt Qty: 1 LB
------------------------------
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: YES
IARC: YES
OSHA: YES
Effects of Exposure: ACUTE:OVEREXP BY INHAL MAY CAUSE IRRIT OF RESP TRACT,
HDCH, DIZZ/DROW. SKIN/EYE CONT:IRRIT & SKIN SENSITIVITY.
CHRONIC:HAZARDOUS MATERIALS LISTED IN INGREDIENTS SECTION MAY AFFECT
FOLLOWING ORGANS: BL OOD, CNS, ALLERGIC RESPIRATORY/SKIN REACTION,
RESPIRATORY TRACT, KIDNEYS, REPRO SYSTEM. NOTE:LEAD (EFTS OF OVEREXP)
Signs And Symptions Of Overexposure: HLTH HAZ:APPEARS ON THE NAVY LIST OF OCCUP
CHEM REPRO HAZARDS. SEEK CONSULTATION FROM APPROP HLTH PROFESSIONALS
CONCERNING LATEST HAZARD LIST INFO & SAFE HANDLING & EXPOSURE INFO
(FP N).
Medical Cond Aggravated By Exposure: UNKNOWN AT THIS TIME.
First Aid: INHAL:REMOVE FROM EXPOSURE. EYES:FLUSH IMMEDIATELY W/LARGE AMOUNTS
& WASH SKIN W/SOAP & WATER. INGEST:DRINK WATER. IF NECESS ARY,
CONSULT MD FOR ANY OF THESE CONDITIONS.
*
Handling and Disposal
*
Spill Release Procedures: REMOVE ALL SOURCES OF IGNITION, AVOID BREATHING
VAPORS, VENTILATE AREA & REMOVE W/INERT ABSORBANT & NON-SPARKING
TOOLS. BEFORE ATTEMPTING CLEAN-UP, SEE HAZARDOUS INGREDIENTS SECTION.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE OF I/A/W LOCAL, STATE & FEDERAL
REGULATIONS.
Handling And Storage Precautions: FLAMMABLE LIQUID. KEEP CONTAINER CLOSED WHEN
NOT IN USE. DO NOT TAKE INTERNALLY.
Other Precautions: CONTAINERS SHOULD BE GROUNDED WHEN POURING. AVOID FREE FALL
OF LIQ IN EXCESS OF A FEW INCHES. MAKE SURE DRUM IS COMPLETELY EMPTY BEFORE
ATTEMPTING TO WELD/BRAZE. DRUM SHOULD BE INDUSTRIALLY CLEANED PR IOR TO
REUSE. DO NOT FLAME CUT, (SUPDAT)
*
Fire and Explosion Hazard Information
*
Flash Point Method: SCC
Extinguishing Media: USE WATER FOG, FOAM, DRY CHEMICAL OR CARBON DIOXIDE.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: FLAMMABLE LIQUID - CLASS IB.
*
*
Respiratory Protection: WHERE GEN DILUTION/LOC EXHST FAILS TO ADEQUATELY DILUTE
TWA/PEL OF MATL, THEN RESP PROT SHOULD BE USED AS FOLLOWS: DO NOT BREATHE
VAP/SPRAY MIST. WEAR APPROP, PROPERLY FITTED NIOSH APPRVD RESP WHEN EX POS. A
NIOSH APPRVD AIR LINE (SUPDAT)
Ventilation: PROVIDE GENERAL DILUTION/LOC EXHST VENT TO KEEP TWA & LEL
BELOW ACCEPT LIMITS & TO REMOVE DECOMPOSITION PRODUCTS.
Other Protective Equipment: EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET ANSI
DESIGN CRITERIA (FP N).
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
IS REC OMMENDED.
*
Physical/Chemical Properties
*
Vapor Pres: SEE INGS
Vapor Density: HVR/AIR
Appearance and Odor: NONE SPECIFIED BY MANUFACTURER.
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products: FUMES MAY CONTAIN CARBON MONOXIDE & OXIDES OF
NITROGEN. MAY PRODUCE HAZARDOUS FUMES WHEN HEATED TO DECOMP AS IN WELDING.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
HAZCOM Label
*
Company Name: DIVERSITY WATER TECHNOLOGIES INC
Label Required IND: Y
Status Code: C
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Severe
Contact Hazard: Moderate
Fire Hazard: Severe
Reactivity Hazard: None
Hazard And Precautions: FLAMMABLE. ACUTE:INHALATION:IRRITATION OF RESPIRATORY
TRACT, HEADACHE, DIZZINESS OR DROWSINESS. SKIN/EYE CONTACT:IRRITATION AND
SKIN SENSITIVITY. CHRONIC:CANCER HAZARD. CONTAINS BENZENE WHICH IS LISTE D AS
A HUMAN BLOOD CARCINOGEN (FP N). LEAD APPEARS ON THE NAVY OCCUPATIONAL
CHEMICAL REPRODUCTIVE HAZARDS LIST (FP N). RESPIRATORY AND SKIN ALLERGIC
REACTION. TARGET ORGANS:BLOOD, CENTRAL NERVOUS SYST EM, RESPIRATORY SYSTEM,
SKIN, KIDNEYS, REPRODUCTIVE SYSTEM.
*
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED DUST MASK ABOVE TLV/PEL.
Ventilation:USE GUIDELINES REC BY AMERICAN CONFERENCE OF GOVTL INDUS
HYGIENISTS IN CURRENT EDITION OF "INDUS VENT" CONSIDERING TLV.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:IRON OXIDE
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: DUST CONCENTRATIONS ABOVE THE
PERMISSIBLE EXPOSURE LIMIT MAY CAUSE TEMPORARY UPPER RESPIRATORY
TRACT DISCOMFORT. CHRONIC: NONE
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:
* First Aid Measures *
First Aid:INHAL: REMOVE TO FRESH AIR. EYES: FLUSH EYES WITH PLENTY OF
LIDS. SKIN: WASH WITH WATER AND MILD SOAP OR WATERLESS HAND CLEANER
TO R EMOVE IRON OXIDE DUST. INGEST: ENTRY BYMOUTH IS NOT LIKELY TO
PRODUCE ADVERSE EFFECTS.
* Fire Fighting Measures *
Extinguishing Media:WATER SPRAY
Fire Fighting Procedures:NORMAL FOG OR NOZZLE JET APPLICATION AND/OR
EXCLUSION OF AIR. WEAR NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE. HMIS HAZARD CLASS FOR FLAMMABILITY:
0
* Accidental Release Measures *
Spill Release Procedures:VACUUM UP.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:KEEP IN CLOSED CONTAINERS.
Other Precautions:
* Physical/Chemical Properties *
HCC:N1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:YELLOW, DRY POWDER
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:NONE
* Disposal Considerations *
Waste Disposal Methods:BURY IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
Control Measures
*
Proprietary Ind: Y
*
Contractor Summary
*
*
Item Description Information
*
Item Manager: GSA
Item Name: INK,CARTRIDGE
Unit of Issue: EA
UI Container Qty: 0
*
Ingredients
*
-----------------------------
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: NO
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE: SKIN/EYE: ALL INKS NON-IRRITATING. DYES IN INK MAKE
EXPOSURE EASY TO DETECT. SYMPTOMS OF EXPOSURE ARE DESRIBED BELOW. EYE:
CONTACT WITH EYES MAY CAUSE IRRITATION. SKIN: NONE OF THE INKS ARE TOX IC BY
SKIN CONTACT. CONTACT W/SKIN MAY CAUSE IRRITATION. INGEST: INGESTION OF INK
MAY RESULT IN GASTRIC DISTURBANCES.
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
WASH AFFECTED AREA WITH SOAP AND WATER. INGEST: DILUTE WITH WATER. GET
MEDICAL ATTENTION. INHAL: REMOVE TO FRESH AIR. SUPPORT BREATHIN G (GIVE
O*2/ARTF RESP)(FP N).
*
Handling and Disposal
*
Spill Release Procedures: USE ABSORBENT TOWEL TO WIPE UP INK. RINSE AREA WITH
DAMP CLOTH TO REMOVE REMAINING TRACES OF INK.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE FEDERAL,
STATE AND LOCAL LAWS.
Handling And Storage Precautions: KEEP OUT OF REACH OF CHILDREN. AVOID CONTACT
BETWEEN THE GOLD CARTRIDGE FACE AND EYES, SKIN AND CLOTHING.
Other Precautions: RAPID REMOVAL OF INK WITH SOAP AND WATER FROM SKIN PREVENTS
IRRITATION AND STAINING.
*
Fire and Explosion Hazard Information
*
Extinguishing Media: WATER, DRY CHEMICAL, CARBON DIOXIDE, FOAM.
Fire Fighting Procedures: WEAR NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: NONE SPECIFIED BY MANUFACTURER.
*
*
Respiratory Protection: NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE
OF CONCERN (FP N).
Ventilation: NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment: NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
*
Physical/Chemical Properties
*
Vapor Density: 3.0
Spec Gravity: 1.1
Solubility in Water: COMPLETELY MISCIBLE
Appearance and Odor: COLORED LIQUID, PRACTICALLY ODORLESS
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: NONE
Hazardous Decomposition Products: NONE
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
Transportation Information
*
Multiple KIT Number: 0
Review IND: Y
Unit Of Issue: EA
Container QTY: 0
Additional Data: NOT REGULATED FOR TRANSPORTATION
*
Detail DOT Information
*
DOT PSN Code: ZZZ
DOT Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
*
Detail IMO Information
*
IMO PSN Code: ZZZ
IMO Proper Shipping Name: NOT REGULATED FOR THIS MODE OF TRANSPORTATION
*
Detail IATA Information
*
IATA PSN Code: ZZZ
IATA Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
*
Detail AFI Information
*
AFI PSN Code: ZZZ
AFI Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
*
HAZCOM Label
*
Company Name: HEWLETT-PACKARD CO, CORPORATE HQ
Label Required IND: Y
Status Code: C
Origination Code: G
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: AVOID CONTACT BETWEEN THE GOLD CARTRIDGE FACE AND EYES,
SKIN AND CLOTHING. ACUTE: EYE/SKIN: MAY CAUSE IRRITATION ON CONTACT. INGEST:
MAY RESULT IN GASTRIC DISTURBANCES. CHRONIC: NONE LISTED BY MANUFAC TURER.
*
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NOT EXPECTED TO BE NECESSARY UNDER NORMAL
CONDITIONS OF USE. WHERE EXPOSURE CANNOT BE ADEQUATELY CONTROLLED
BY GENERAL OR LOCAL VENTILATION, USE APPROPRIATE NIOSH APPROVED
RESPIRATORY PROTECTION TO PR EVENT OVEREXPOSURE. A NIOSH APPROVED
DUST/MIST RESPIRATOR WOULD BE RECOMMENDED.
Ventilation:LOCAL EXHAUST: AS NECESSARY. MECHANICAL (GENERAL):
ADEQUATE. SPECIAL/OTHER: NOT APPLICABLE.
FACESHIELD .
Other Protective Equipment:ANSI APPROVED EMERGENCY EYE WASH AND DELUGE
SHOWER . OTHER PROTECTIVE CLOTHING OR EQUIPMENT NOT REQUIRED.
Work Hygienic Practices:FOLLOW OSHA MANDATED PROCEDURES. NEVER EAT OR
SMOKE WHILE WORKING WITH CHEMICALS. GOOD HOUSEKEEPING PRACTICES
APPLY. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
* Product Identification *
CAGE:CANBE
CAGE:CANBE
* Composition/Information on Ingredients *
Ingred Name:2-BUTOXYETHANOL
Minumum % Wt:1.
Maxumum % Wt:5.
Ingred Name:PHOSPHORIC ACID
Minumum % Wt:1.
Maxumum % Wt:5.
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3
ACGIH STEL:3 MG/M3
Ingred Name:DODECYLBENZENESULFONIC ACID
Minumum % Wt:1.
Maxumum % Wt:5.
Ingred Name:HYDROXYACETIC ACID
Minumum % Wt:1.
Maxumum % Wt:5.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: HARMFUL IF SWALLOWED. EYE AND
SKIN IRRITANT. MAY CAUSE PERMANENT DAMAGE. CAN IRRITATE MUCOUS
MEMBRANES AND RESPIRATORY TRACT. CHRONIC: NONE KNOWN. NOTE: ANIMAL
STUDIES CLEARLY DEMONSTRATED DOSE -RELATED ADVERSE EFFECTS ON
CENTRAL NERVOUS SYSTEM, HEMATOPOIETIC TISSUES, BLOOD, KIDNEYS, AND
LIVER, ASSOCIATED WITH THE ADMINISTRATION OF ETHYLENE GLYCOL
MONOBUTYL ETHER (EGBE) (EXTRACTED FROM DHHS (NIOSH) PUBLICATION
Explanation of Carcinogenicity:NO CHEMICALS LISTED AS CARCINOGENS OR
POTENTIAL CARCINOGENS: NATIONAL TOXICOLOGY PROGRAM; I.A.R.C.
MONOGRAPHS; OR OSHA.
Effects of Overexposure:IRRITATION OR BURNING SENSATION. COUGHING OR
CHOKING SENSATION.
Medical Cond Aggravated by Exposure:MAY AGGRAVATE SKIN DISORDERS OR
RESPIRATORY AILMENTS.
* First Aid Measures *
MINUTES. GET MEDICAL ATTENTION. SKIN CONTACT: FLUSH WITH WATER FOR
MOUTH W ITH WATER. THEN DRINK 1-2 GLASSES OF WATER. NEVER GIVE
ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. GET IMMEDIATE MEDICAL
ATTENTION. INHALATION: MOVE TO FRESH AIR. GET IMMEDIATE MEDICAL
ATTENTION.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:N/E
Upper Limits:N/E
Extinguishing Media:WATER, CO*2, FOAM OR MEDIA SUITABLE FOR SURROUNDING
FIRE.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . STANDARD FIRE FIGHTING PROCEDURES MAY BE FOLLOWED.
Unusual Fire/Explosion Hazard:NONE KNOWN. HMIS RATINGS: HEALTH - 2;
FLAMMABILITY - 2; REACTIVITY - 0.
* Accidental Release Measures *
Spill Release Procedures:WEAR APPROPRIATE PROTECTIVE EQUIPMENT. IF
POSSIBLE, CONTAIN SPILL AND COLLECT IN AN APPROVED CONTAINER. RINSE
AFFECTED AREA THOROUGHLY WITH WATER. KEEP PRODUCT OUT OF SEWERS OR
WATERWAYS. HOLD FOR DIS POSAL.
*Handling and Storage *
Handling and Storage Precautions:AVOID CONTACT WITH SKIN OR EYES. AVOID
BREATHING VAPOR, SPRAY OR MIST. STORE IN ORIGINAL CONTAINER, IN
COOL, DRY PLACE WITH ADEQUATE VENTILATION. KEEP OUT OF REACH OF
CHILDREN. KEEP CONTAINER TIGHTLY CLOSED WHEN NOT IN USE.
Other Precautions:USE ONLY ACCORDING TO LABEL DIRECTIONS. IF UNSURE
ABOUT SAFE USE, CONTACT YOUR SUPERVISOR IMMEDIATELY.
* Physical/Chemical Properties *
B.P. Text:APPROXIMATELY
pH:<1 (CONC)
Evaporation Rate & Reference:1 (H*2O=1) (APPROX)
Solubility in Water:COMPLETE
Appearance and Odor:LIGHT BLUE LIQUID; MINT ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
DO NOT MIX WITH OTHER CHEMICALS.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:THERMAL DECOMPOSITION ON BURNING MAY
PRODUCE TOXIC VAPORS OR GASES.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF I/A/W LOCAL, STATE AND FEDERAL
REGULATIONS. IF POSSIBLE, TRIPLE RINSE CONTAINER AND RECYCLE.
* MSDS Transport Information *
Transport Information:DOT: NOT REGULATED. REPORTABLE QUANTITY: NOT
TRANSPORTATION NOTES: COLU MBIAN CHEMICALS COMPANY'S CARBON BLACK
(MINERAL ORIGIN) IS NOT RESTRICTED BY INTERNATIONAL AIR TRANSPORT
ASSOCIATION DANGEROUS GOODS, REGULATIONS OR INTERNATIONAL MARITIME
DANGEROUS GOODS CODE.
* Regulatory Information *
SARA Title III Information:2-BUTOXYETHANOL AND PHOSPHORIC ACID ARE
State Regulatory Information:
* Other Information *
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF DUST CONDITIONS PREVAIL, USE OF AN APPROVED
NIOSH/MSHA DUST MASK IS RECOMMENDED.
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:LONG SLEEVES IF USE REQUIRES MANUAL
HANDLING.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
STAND OPER INSTRUCTIONS. FOLLOWING CONTACT W/TYPICAL
PETROCHEMICALS/GASES, MOLECULAR SIEVES MUST BE HANDLED W/SPECIAL
PRECAUTION S. COMBINATION OF SIEVES & RETAINED MATL CAN BE
FLAMM/TOX. USE APPROVED DISPOSAL METH SUITABLE FOR TOXIC WASTES.
* Product Identification *
Product ID:FORMED MOLECULAR SIEVE, IGE
Preparer's Name:J. H. CONVEY
* Composition/Information on Ingredients *
Ingred Name:SODIUM ALUMINOSILICATE
Ingred Name:CALCIUM SODIUM ALUMINOSILICATE
Ingred Name:POTASSIUM SODIUM ALUMINOSILICATE
Ingred Name:KAOLIN
Ingred Name:CNDTNS (STAB): HOT ENOUGH TO CAUSE THERMAL BURNS OF SKIN.
AVOID CONTACT UNDER THESE CONDITIONS.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:THE DRYING ACTION OF THIS MATERIAL CAN
CAUSE IRRITATION OF THE MUCOUS MEMBRANES OF THE NOSE AND THROAT AND
IRRITATION OF THE SKIN. QUARTZ CAN CAUSE CANCER, SILICOSIS OR OTHER
FIBROTIC LUNG DISEASE WIT H PROLONGED EXPOSURE. AVOID PROLONGED
BRTHG OF DUST OR CONT W/SKIN. WHEN ACTIVATED, ACTS AS DESICCANT
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:CRYSTALLINE SILICA: IARC GRP 2A;NTP
GROUP 2.
Effects of Overexposure:HLTH HAZ: AND CAN CAUSE DRYING IRRITATION OF
MUCOUS MEMBRANES AND SKIN IN CASES OF SEVERE EXPOSURE.
Medical Cond Aggravated by Exposure:DAVISON KNOWS OF NO MEDICAL
CONDITIONS ABNORMALLY AGGRAVATED BY EXPOSURE TO THIS PRODUCT.
* First Aid Measures *
First Aid:EYES: IMMEDIATELY WASH FROM EYES WITH LARGE AMOUNTS OF WATER
IF IRRITATION OCCURS AND PERSISTS, SEEK MEDICAL ATTENTION. SKIN:
WASH WIT H SOAP AND WATER. INGEST: MATERIAL WILLPASS THROUGH BODY
NORMALLY. INHAL: REMOVE TO FRESH AIR.
* Fire Fighting Measures *
Flash Point:NON-FLAMMBLE
Extinguishing Media:USE MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NON-FLAMMABLE. WHEN POURING INTO
FLAMMABLE LIQUID, GROUND BOTH CONTAINERS TO PREVENT STATIC ELEC
SPARK.
* Accidental Release Measures *
Spill Release Procedures:VACUUM OR SWEEP UP OR FLUSH TO SEWER TREATED
FOR SUSPENDED SOLIDS REMOVAL. AVOID CREATING DUST.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINERS TIGHTLY SEALED TO
PROTECT PRODUCT QUALITY. TAKE CARE TO AVOID SOURCES OF IGNITION AND
PERSONAL CONTACT.
Other Precautions:WHEN TRANSFERRING BEADED MOLECULAR SIEVES W/HIGH
W/ENOUGH VELOCITY TO PENETRATE SKIN. MAKE SURE TRANSFER SYSTEM &
RECEIVING VESSELS ARE P ROPERLY GROUNDED. FOLLOW (SUPP DATA)
* Physical/Chemical Properties *
HCC:N1
Spec Gravity:2.1
pH:SUPDAT
Solubility in Water:INSOLUBLE
Appearance and Odor:WHITE, GRAY OR TAN BEADS; ODORLESS.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
REACTS WITH HF AND STRONG ACIDS OR ALKALI & WATER.
Stability Condition to Avoid:WILL RELS HEAT WHEN ADBSORBING H*2O. IF LG
AMT OF SIEVE QUICKLY ADBSORB EQUILIBRIUM AMT OF H*2O, SIEVE CAN
BECOME (ING 5
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
* Disposal Considerations *
Waste Disposal Methods:LANDFILL I/A/W LOCAL, STATE AND FEDERAL
REGULATIONS. COVER TO AVOID BLOWING OF DUST.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH APPROVED RESPIRATOR APPROPRIATE FOR
WORKPLACE CONDITIONS WAR RANT A RESPIRATOR'S USE.
Ventilation:USE ADEQUATE VENTILATION TO KEEP AIRBORNE CONCENTRATIONS
LOW.
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER . WEAR
APPROP PROT CLTHG TO PREVENT SKIN EXPOSURE.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. REMOVE
CONTAMINATED CLOTHING & WASH BEFORE REUSE.
Supplemental Safety and Health
FIRST AID PROC:TO FRESH AIR IMMED. IF NOT BRTHG, GIVE ARTF RESP. IF
BRTHG IS DFCLT, GIVE OXYG. NOTES TO PHYS:TREAT SYMPTOMATICALLY &
SUPPORTIVELY.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:1,3 PROPANEDIOL, 2-AMINO-2-(HYDROXYMETHYL)-;
(TRIS-(HYDROXYMETHYL)AMINOMETHANE)
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYE:MAY CAUSE IRRITATION.
SKIN:MAY CAUSE IRRITATION. INGEST:MAY CAUSE SEVERE GASTROINTESTINAL
TRACT IRRITATION WITH NAUSEA, VOMITING & POSSIBLE BURNS. INHAL:MAY
CAUSE IRRITATION OF RESPIRATORY T RACT WITH BURNING PAIN IN NOSE &
THROAT, COUGHING, WHEEZING, SHORTNESS OF BREATH AND PULMONARY
EDEMA. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:CHRONIC:PROLONGED OR REPEATED SKIN
CONTACT MAY CAUSE DERMATITIS. SENSITIZER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
LIFTING UPPER & LOWER LIDS. GET MED AID IMMED. SKIN:GET MED AID.
CONTAMD CLTHG & SHOES. INGEST:IF VICTIM IS CONSCIOUS & ALERT, GIVE
2-4 CUPFULS OF MILK/WATER. NEVER GIVE ANYTHING BY MOUTH TO UNCON
PERSON. GET MED AID IMMED. INHAL:GET MED AID IMMED. REMOVE FROM
EXPOS (SUPDAT)
* Fire Fighting Measures *
Extinguishing Media:USE WATER, DRY CHEMICAL, CHEMICAL FOAM, OR
ALCOHOL-RESISTANT FOAM.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
* Accidental Release Measures *
Spill Release Procedures:CLEAN UP SPILLS IMMED, OBSERVING PRECAUTIONS
IN PROTECTIVE EQUIPMENT SECTION. SWEEP UP, THEN PLACE INTO A
SUITABLE CLEAN, DRY CONTAINER FOR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE. KEEP AWAY
FROM ACIDS. KEEP CONTAINERS TIGHTLY CLOSED.
Other Precautions:USE WITH ADEQUATE VENTILATION. AVOID CONTACT WITH
EYES, SKIN, AND CLOTHING. AVOID INGESTION AND INHALATION. DISCARD
CONTAMINATED SHOES.
* Physical/Chemical Properties *
Evaporation Rate & Reference:NOT AVAILABLE
Solubility in Water:MODERATELY SOLUBLE
Appearance and Odor:FINE, WHITE CRYSTALLINE POWDER. DELIQUESCENT. ABINE
ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
BASES, OXIDIZING AGENTS, ACIDS, ALDEHYDES, COPPER, BRASS, AND ALUMINUM.
Stability Condition to Avoid:INCOMPATIBLE MATERIALS.
Hazardous Decomposition Products:NITROGEN OXIDES, CARBON MONOXIDE,
CARBON DIOXIDE, NITROGEN.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN A MANNER CONSISTENT WITH FEDERAL,
STATE, AND LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATORY.
Ventilation:MECHANICAL (GENERAL)/LOCAL EXHAUST: ESPECIALLY IN CONFINED
AREAS.
Other Protective Equipment:BARRIER CREAM
Work Hygienic Practices:WASH HANDS BEFORE EATING/SMOKING/USING WASH
ROOM. REMOVE/LAUNER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
DON'T SMOKE IN ANY CHEMICAL HANDLING/STORAGE AREA. FOOD/BEVERAGES
SHOULDN'T BE CONSUMED IN AREAS IMMEDIATE TO USE OF THIS PRODUCT.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:PROPYLENEGLYCOL MONOMETHYL ETHER ACETATE,
1-METHOXY-2-PROPANOL ACETATE
Ingred Name:TITANIUM DIOXIDE, TIO2
Ingred Name:TOLUENE
Fraction by Wt: <5%
Ingred Name:ACRYLIC POLYMER
Ingred Name:PIGMENT
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: IRRITATION TO RESPIRATORY
SYSTEM. SKIN: IRRITANT, DERMATITIS. EYE: IRRITANT. MAY CAUSE
LIVER/KIDNEY DAMAGE. OVEREXPOSURE TO SOLVENT MAY CAUSE PERMANENT
CENTRAL NERVOUS SYSTEM DAMAGE. MAY C AUSE LONG TERM RESPIRATORY
DAMAGE. ASPIRATION OF MATERIAL TO THE LUNGS CAUSES CHEMICAL
PNEUMONITIS/FATAL.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:DRYNESS OF THROAT, TIGHTNESS OF THE CHEST,
SHORTNESS OF BREATH, IRRITATION.
Medical Cond Aggravated by Exposure:RESPIRATORY ALLERGIES, CHRONIC
DISEASE OF THE SKIN/NOSE/THROAT/RESPIRATORY TRACT/CENTRAL NERVOUS
SYSTEM/LIVER/KIDNEY/HEART/EYES/GI TRACT.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR, GIVE CPR IF NECESSARY. SKIN:
WASH W/SOAP & WATER. INGESTION: DON'T INDUCE VOMITING. KEEP
MINS. OBTA IN MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Flash Point Method:PMCC
Lower Limits:1.3
Extinguishing Media:CO2, DRY CHEMICAL, FOAM, WATER FOG
Fire Fighting Procedures:WEAR SCBA/PROTECTIVE EQUIPMENT. REMOVE ALL
IGNITION SOURCES. USE A WATER SPRAY TO COOL FIRE EXPOSED
CONTAINERS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY BE EXPLODE WHEN
EXPOSED TO EXTREME HEAT. VAPORS MAY TRAVEL ALONG GROUND TO IGNITION
SOURCES. RESULTING IN A FLASH BACK.
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. WEAR
APPROPRIATE PROTECTIVE EQUIPMENT. DIKE/ABSORB W/INERT ABSORBENT
MATERIAL/COLLECT IN OPEN CONTAINERS FOR DISPOSAL. FLUSH
CONTAMINATED AREA W/WATER/COLLECTING FOR DI SPOSAL.
*Handling and Storage *
Handling and Storage Precautions:STORE IN COOL DRY PLACE WITH ADEQUATE
VENTILATION, AWAY FORM IGNITION SOURCES. KEEP CLOSURE
TIGHT/CONTAINER UPRIGHT TO PREVENT LEAKAGE.
Other Precautions:DON'T FLAME CUT/WELD EMPTY CONTAINER/DRUM. OBSERVE
CONDITIONS OF GOOD INDUSTRIAL HYGIENE/SAFE WORKING PRACTICE.
* Physical/Chemical Properties *
Vapor Density:>1
Evaporation Rate & Reference:(BU AC=1): <1
Solubility in Water:SLIGHT
Appearance and Odor:PIGMENTED LIQUID W/SLIGHT SOLVENT ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:EXCESSIVE HEAT/OPEN FLAMES/SPARKS.
Hazardous Decomposition Products:CO/CO2
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL/STATE/LOCAL REGULATIONS.
EMPTY CONTAINERS MUST BE HANDLED W/CARE DUE TO PRODUCT RESIDUE.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF VENTILATION ALONE CANNOT SO CONTROL EXPOSURE,
Ventilation:VENT IS NORM REQD WHEN HNDLG/USING PROD TO KEEP EXPOS TO
AIRBORNE NICKEL BELOW EXPOS LIMIT. MAINTAIN AIRBORNE (SUPDAT)
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH SKIN THOROUGHLY AFTER HANDLING. LAUNDER
Supplemental Safety and Health
HAZ DECOMP PROD: AN EXTREM TOX GAS. NICKEL CAN REACT W/ACIDS TO
LIBERATE H2 GAS WHICH CAN FORM EXPLO MIX IN AIR. NICKEL CAN REACT
EXPLO OR INCANDESCENTLY W/AMMONIUM NITRATE, PERCHLORATES,
PHOSPHOROUS, SELENIUM, SULFUR. VENT: CONC OF NICKELOXIDE AS LOW AS
POSS. SPILL PROC: EXPOS LIMITS. EFTS OF OVEREXP: SINGLE (ING 4)
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:ING 8: REASONABLY ANTICIPATED TO BE CARCIN BASED ON
Ingred Name:ING 9: SUFF EVIDENCE THAT NICKEL CMPDS ARE CARCIN TO HUMANS
WITH POTENTIAL CARCINOGENICITY OF NICKEL CARBIDE.
OSHA PEL:1 MG/M3
Fraction by Wt: 0.3%
OSHA PEL:1 MG/M3 (NI)
Fraction by Wt: 1.6%
OSHA PEL:1 MG/M3 (NI)
Ingred Name:SUPP DATA: INTRATRACHEAL INSTILLATIONS OF NICKEL POWDER IN
Ingred Name:ING 4:OF FIBROSARCOMAS, MESOTHELIOMAS & RHABDOMYOSARCOMAS.
Ingred Name:ING 5:TRACT IN RODENTS. SKIN:RPTD CONT W/METALLIC NICKEL
CAN CAUSE NICKEL SENSIT & ALLERGIC SKIN RASHES. WOUNDS: (ING 7)
Ingred Name:ING 6:NICKEL METAL POWDER HAS CAUSED TUMORS AT SITE OF
INJECT IN RODENTS. HOWEVER, STUDIES DO NOT SUGGEST (ING 8)
Ingred Name:ING 7:SIGNIFICANT RISK FOR HUMANS FROM NICKEL-CONTAINING
PROSTHESES. ING 2:INHAL: NTP HAS LISTED NICKEL OXIDE AS (ING 9)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ING 1:NTP HAS LISTED NICKEL AS
REASONABLY ANTICIPATED TO BE CARCIN BASED ON PRODUCTION OF
INJECT-SITE TUMORS. IARC FOUND THERE WAS INADEQ EVIDENCE THAT
METALLIC NICKEL IS CARCIN TO HUMANS BUT SINCE TH ERE WAS SUFF
EVIDENCE THAT IT IS CARCINTO ANIMALS, IARC CONCLUDED THAT METALLIC
NICKEL IS POSS CARCIN (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NICKEL AND NICKEL COMPOUNDS: GROUP 1
(IARC), GROUP 2 (NTP).
Effects of Overexposure:HLTH HAZ: TO HUMANS. EPIDEMIOLOGICAL STUDIES OF
WORKERS EXPOS TO NICKEL POWDER & TO DUST/FUME GEN IN PRODUCTION OF
NICKEL ALLOYS & OF STAINLESS STEEL HAVE NOT INDICATED PRESENCE OF
SIGNIFICANT RESP CA NCER HAZ. RPTD INTRACHEAL INSTILLATION OF
NICKEL POWDER PRDCD INCR INCIDENCE OF MALIGNANT LUNG TUMORS IN
RATS. (SUPDAT)
Medical Cond Aggravated by Exposure:SKIN CONTACT CAN CAUSE AN ALLERGIC
SKIN RASH IN PREVIOUSLY SENSITIVE INDIVIDUALS.
* First Aid Measures *
First Aid:IF EXPOSURE TO NICKEL CARBONYL IS SUSPECTED, SEEK MEDICAL
ATTENTION IMMEDIATELY. SKIN: FOR RASHES, SEEK MEDICAL ATTENTION.
CLEANSE WOUNDS THOROUGHLY TO REMOVE ANY PARTICLES. INHALATION:
REMOVE FROM EX POSURE. SUPPORT BREATHING (GIVE ARTIFICIAL
RESPIRATION/ OXYGEN) . INGESTION: CALL MD IMMEDIATELY . EYES: FLUSH
* Fire Fighting Measures *
Extinguishing Media:USE MEDIA SUITABLE FOR SURROUNDING FIRE CONDITIONS
.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:METAL POWDERS HEAT TREATED IN REDUCING
ATMOSPHERES MAY BECOME PYROPHORIC.
* Accidental Release Measures *
Spill Release Procedures:COLLECT SPILLS BY WET SWEEPING/BY VACUUMING
W/VACUUM EXHST PASSING THRU HEPA FILTER IF EXHST IS DISCHARGED INTO
WORKPLACE.WEAR APPROP NIOSH/MSHA APPRVD RESP IF COLLECTION/DISP OF
SPILLS IS LIKELY TO C AUSE CONC OF AIRBORNE CONTAM TO EXCEED
(SUPDAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:DO NOT INHALE POWDER. KEEP CONTAINER
CLOSED WHEN NOT IN USE. AVOID REPEATED SKIN CONTACT.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
* Physical/Chemical Properties *
HCC:T6
Boiling Pt:B.P. Text:SEE ING 1
Melt/Freeze Pt:M.P/F.P Text:SEE ING 1,2
Spec Gravity:SEE INGREDIENTS
Solubility in Water:0%
Appearance and Odor:GRAY, ODORLESS POWDER WITH AN AVERAGE SIZE OF
2.5-3.1 MICRONS.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ACIDS OR REACTIVE SUBSTANCES.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:UNDER SPEC CNDTNS NICKEL CAN REACT
W/CARBON MONOXIDE IN REDUCING ATMOSPHERES TO FORM NICKEL CARBONYL,
NO(CO)4, (SUPDAT)
* Disposal Considerations *
Waste Disposal Methods:NICKEL-CONTAINING WASTE IS NORMALLY COLLECTED TO
RECOVER NICKEL VALUES. SHOULD WASTE DISPOSAL BE DEEMED NECESSARY
FOLLOW FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NO SPECIAL MEASURES ARE REQUIRED.
Ventilation:NO SPECIAL MEASURES ARE REQUIRED.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:SODIUM LINEAR ALKYL NAPHTHALENE SULFONATE,
Fraction by Wt: <5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:TETRASODIUM ETHYLENEDIAMINE TETRAACETATE
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:UNKNOWN Skin:UNKNOWN Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MSDS DATA PERTAINS TO PRODUCT AS
DISPENSED FROM CONTAINER. ADVERSE HEALTH EFFECTS NOT EXPECTED UNDER
RECOMMENDED USE CONDITIONS (DILUTED) SO LONG AS PRESCRIBED SAFETY
PRECAUTIONS ARE PRACTICED. THIS P RODUCT, PARTICULARLY IN ITS
CONCENTRATEDFORM, MAY IRRIT EYES & SKIN UPON CONTACT. INFLAMMATION
OF THE EYE IS CHARACTERIZED BY REDNESS, WATERING, AND ITCHING. SKIN
INFLAMMATION IS CHARACTERIZED BY ITCH ING, SCALING, REDDENING, OR
BLISTERING. THERE ARE NO KNOWN EFFECTS FRO CHRONIC EXPOSURE TO THIS
PRODUCT.
Effects of Overexposure:NONE
Medical Cond Aggravated by Exposure:NONE
* First Aid Measures *
MIN. GET MED ATTEN IF IRRIT DEVELOP. EYES: IMMED FLUSH EYES W/LOTS
MED A TTEN AT ONCE. INHALE: MOVE EXPOSED PERSON TO FRESH AIR. IF
IRRIT PERSIST, GET MED ATTEN PROMPTLY. INGEST: DON'T INDUCE
VOMITING. IF VICTIM IS CONSCIOUS GIVE LOTS OF WATER TO DRINK.GET
MED ATTEN @ ONCE
* Fire Fighting Measures *
Flash Point Method:TCC
Flash Point:NONE
Extinguishing Media:NON-COMBUSTIBLE LIQUID
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:MAY DECOMPOSE TO FORM TOXIC/CORROSIVE
GASES.
* Accidental Release Measures *
Spill Release Procedures:OBSERVE SAFETY PROCEDURES IN MSDS. ABSORB
SPILL ON INERT ABSORBENT MATERIAL (EG ZEP -O-ZORB) PICK UP & PLACE
RESIDE IN A SUITABLE WASTE CONTAINER OR, IF PERMITTED, FLUSH TO
SEWER. THOROUGHLY RINSE SPI LL AREA WITH WATER.
*Handling and Storage *
Other Precautions:STORE TIGHTLY CLOSED CONTAINER IN DRY AREA AT
PROLONGED CONTACT WITH SKIN. KEEP OUT OF REACH OF CHILDREN.
Other Protective Equipment:*IS STRONGLY RECOMMEND FOR PROLONG CONTACT.
Supplemental Safety and Health
* Physical/Chemical Properties *
pH:9.2-9.7
Evaporation Rate & Reference:1.0(WATER=1)
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, LIGHT AMBER LIQUID WITH VERY LITTLE ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:STRONG OXIDIZING AGENTS
Hazardous Decomposition Products:MAY DECOMPOSE TO FORM TOXIC/CORROSIVE
GASES IF EXPOSED TO HIGH HEAT.
Conditions to Avoid Polymerization:STRONG OXIDIZING AGENTS
* Disposal Considerations *
Waste Disposal Methods:LIQUID WASTES ARE NOT PERMITTED IN LANDFILLS.
PROD IS NOT CONSIDERED HAZ WASTE UNDER RCRA. UNUSABLE LIQUID MAY BE
ABSORBED ON INERT ABSORBENT MATERIALL, DRUMMED, & TAKEN TO
CHEMICAL/INDUSTRIAL LANDFIL L. SOME AREAS DISPOSAL BY FLUSHING INTO
SANITARY SEWER W/ PLENTY H2O MAY BE PERMISSIBLE. CONSULT LOC
AL/STATE/FED AGENCIES FOR PROPER DISPOSAL METHOD.
* Regulatory Information *
State Regulatory Information:EPA TSCA CHEMICAL INVENTORY: ALL
INGREDIENTS ARE LISTED.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF EXPOSURE MAY OR DOES EXCEED OCCUPATIONAL
EXPOSURE LIMITS. USE A NIOSH - APPROVED RESPIRATOR TO PREVENT
OVEREXPOSURE.
Ventilation:USE EXPLOSION PROOF VENTILATION AS REQUIRED TO CONTROL
VAPOR CONCENTRATIONS.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . WEAR PROTECTIVE CLOTHING AS REQUIRED TO
PREVENT SKIN CONTACT.
Work Hygienic Practices:WASH WITH SOAP AND WATER AFTER HANDLING AND
BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES.
LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:LEAD
Minumum % Wt:2.
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Minumum % Wt:.8
OSHA PEL:see Table Z-2
Ingred Name:HEAVY STRAIGHT RUN NAPHTHA (PETROLEUM); (MINERAL SPIRITS).
Minumum % Wt:3.
Ingred Name:PIGMENTS
Ingred Name:LEAD CHROMATE
Ingred Name:MOLYBDATE ORANGE
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION: NAUSEA, DIZZINESS,
HEADACHE, VOMITING. SKIN: REPEATED CONTACT MAY CAUSE IRRITATION,
DEFATTING AND DERMATITIS. EYE: CAUSES IRRITATION, REDNESS, TEARING,
BLURRED VISION. INGESTION: C AN CAUSE IRRITATION OF THE DIGESTIVE
TRACT, NAUSEA, VOMITING & DIARRHEA. ASPIRATION INTO THE LUNGS CAN
CAUSE CHEMICAL PNEUMONITIS WHICH CAN BE FATAL. CHRONIC: LEAD
APPEARS ON THE NAVY LISTING OF OCCUP ATIONAL CHEMICAL REPRODUCTIVE
HAZARDS. SEEK CONSULTATION FROM APPROPRATE HEALTH PROFESSIONALS
CONCERNING LATEST HAZARD LIST INFORAMTION AND SAFE HANDLING AND
EXPOSURE INFORMATION . (EFTS OF OVE REXP).
Explanation of Carcinogenicity:LEAD CHROMATE: IARC MONOGRAPHS, VOLUME
Effects of Overexposure:HLTH HAZ: NOTICE: REPORTS HAVE ASSOCIATED
REPEATED AND PROLONGED OCCUPATIONAL OVEREXPOSURE TO SOLVENTS WITH
PERMANENT BRAIN & NERVOUS SYSTEM DAMAGE. INTENTIONAL MISUSE BY
DELIBERATELY CONCENTRATING AN D INHALING THIS PRODUCT MAY BE
HARMFUL OR FATAL. PRODUCTS CONTAINING LEAD CHROMATE: (SEE SECTION
2) PROLONGED OR REPEATED EXPOSURE FROM POOR HYGIENE, HOUSEKEEPING
OR HANDLING PRACTICES CAUSES LEAD POI SONING. PROLONGED
OVEREXPOSURE MAY CAUSE DELAYED EFFECTS INVOLVING THE BLOOD,
GASTROINTESTINAL, NERVOUS & REPRODUCTIVE SYSTEMS. LEAD CHROMATE IS
CURRENTLY LISTED AS A SUSPECTED CARCINOGEN.
Medical Cond Aggravated by Exposure:PRE-EXISTING EYE, SKIN OR
RESPIRATORY DISORDERS. ANEMIA.
* First Aid Measures *
MINUTES. IF IRRITATION PERSISTS, SEEK MEDICAL ATTENTION. SKIN: WASH
WITH SOAP AND WATER. SEEK MEDICAL ATTENTION IF IRRITATION DEVELOPS.
INHALA TION: REMOVE TO FRESH AIR. GIVE ARTIFICIAL RESPIRATION IF
NECESSAARY. GET MEDICAL ATTENTION. INGESTION: DO NOT INDUCE
VOMITING. SEEK MEDICAL ATTENTION IMMEDIATELY.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:0.9%
Upper Limits:6.0%
Extinguishing Media:DRY CHEMICAL, CARBON DIOXIDE, FOAM.
Fire Fighting Procedures:USE NIOSH APPROVED SELF CONTAINED BREATHING
APPARATUS & FULL PROTECTIVE EQUIPMENT . WATER SPRAY MAY BE USED TO
COOL CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE
FROM HEAT, SPARKS AND OPEN FLAME. CLOSED CONTAINERS MAY EXPLODE
WHEN EXPOSED TO EXTREME HEAT. OVEREXPOSURE TO DECOMPOSITION
PRODUCTS MAY CAUSE HEALTH HAZARD. SY MPTOMS MAY NOT BE IMMEDIATELY
APPARENT. OBTAIN MEDICAL ATTENTION.
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. COVER WITH
INERT ABSORBENT MATERIAL.
*Handling and Storage *
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS AND OPEN
FLAME. KEEP CONTAINERS TIGHTLY CLOSED. STORE AWAY FROM STRONG
OXIDIZING AGENTS IN A COOL DRY PLACE WITH ADEQUATE EXPLOSION PROOF
VENTILATION. AVOID BREATHING VAPOR S. AVOID CONTACT WITH EYES, SKIN
AND CLOTHING.
Other Precautions:DO NOT WELD, HEAT OR DRILL ON OR NEAR CONTAINER; EVEN
EMPTIED CONTAINERS CAN CONTAIN EXPLOSIVE VAPORS. UNIFORMS OR
CLOTHING CONTAINING PAINT RESIDUE SHOULD NOT BE LAUNDERED WITH
HOUSEHOLD GARMENTS. DO NOT TAKE INTERNALLY. OBSERVE LABEL
PRECAUTIONS.
* Physical/Chemical Properties *
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN BUTYL ACETATE
Solubility in Water:NEGLIGIBLE
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ISOLATE FROM OXIDIZERS, HEAT, SPARKS AND OPEN FLAME.
Stability Condition to Avoid:HEAT, SPARKS AND OPEN FLAME.
Hazardous Decomposition Products:MAY PRODUCE FUMES WHEN HEATED TO
DECOMPOSITION. FUMES MAY CONTAIN CARBON MONOXIDE AND/OR CARBON
DIOXIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR UNDER NORMAL
CONDITIONS.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF PRODUCT IN ACCORDANCE WITH LOCAL,
COUNTY, STATE AND FEDERAL REGULATIONS.
* MSDS Transport Information *
Transport Information:DOT: COMBUSTIBLE LIQUID.
* Regulatory Information *
SARA Title III Information:SUBJECT TO THE REPORTING REQUIREMENTS OF
AMENDMENTS AND REAUTHORIZATION ACT(SARA) HAS CREATED NEW
REPORTING REQUIREMENTS FOR COMPANIES THAT HANDLE CERTAIN CHEMICALS
AND CHEMICAL CATEGORIES. THE FOLLOWING IS A LIST OF CHEMICALS
AND THE PRODUCTS THAT CONTAIN THOSE CHEMICALS: COPPER PTHALO BLUE
Federal Regulatory Information:OSHA: COMBUSTIBLE LIQUID - CLASS II.
State Regulatory Information:WARNING: THIS PRODUCT AND THE CONTAINER IT
IS IN CONTAIN DETECTABLE AMOUNTS OF ONE OR MORE CHEMICALS KNOWN TO
THE STATE OF CALIFORNIA TO CAUSE CANCER, BIRTH DEFECTS OR OTHER
REPRODUCTIVE HARM.
* Other Information *
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NOT REQUIRED UNDER NORMAL PRODUCT USAGE.
Ventilation:NOT REQUIRED UNDER NORMAL PRODUCT USAGE.
Other Protective Equipment:NOT REQUIRED UNDER NORMAL PRODUCT USAGE.
Work Hygienic Practices:GOOD PERSONAL HYGIENE SHOULD BE PRACTICED.
Supplemental Safety and Health
WASTE CONT'D: CAREFULLY READ & FOLLOW DIRECTIONS. DISPOSE OF
IAW/FEDERAL, STATE & LOCAL REGULATIONS.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:PREPARED PLATED MEDIA CLASSIFIED AS GENERAL IN USE
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INDIVIDUALS W/KNOWN/SUSPECTED
ALLERGIES SHOULD ADVISE PHYSICIAN OF INCIDENT THAT MAY HAVE
RESULTED IN EXPOSURE TO ANTIBIOTIC TREATED MEDIA.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INDIVIDUALS W/KNOWN/SUSPECTED ALLERGIES SHOULD
ADVISE PHYSICIAN OF INCIDENT THAT MAY HAVE RESULTED IN EXPOSURE TO
ANTIBIOTIC TREATED MEDIA.
* First Aid Measures *
First Aid:OBTAIN MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Extinguishing Media:WATERSPRAY
Fire Fighting Procedures:IF PRODUCT BECOMES INVOLVED IN A FIRE,
EXTINGUISHING MEDIA FOR SURROUNDING MATERIAL SHOULD BE APPROPRIATE.
Unusual Fire/Explosion Hazard:PRODUCT WILL NOT BURN.
* Accidental Release Measures *
Spill Release Procedures:USE PAPER TOWELS TO PICK UP MATERIAL. WASH
AREA W/SOAP & WATER AFTER CLEANUP IS COMPLETE.
* Physical/Chemical Properties *
Appearance and Odor:GELLED MEDIA OF VARYING COLORS.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
* Disposal Considerations *
Waste Disposal Methods:OBSERVE ASEPTIC TECHNIQUES & ESTABLISHED
PRECAUTIONS AGAINST MICROBIOLOGICAL HAZARDS THROUGHOUT ALL
PROCEDURES. AFTER, USE PREPARED PLATES, SPECIMEN CONTAINERS & OTHER
CONTAMINATED MATERIALS, MUST BE STERILIZED BY AUTOCLAVING. (SEE
SUPP)
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:RESPIRATORY PROTECTION NOT NEEDED UNDER NORMAL
USAGE CONDITIONS.
Ventilation:ADEQUATE VENTILATION IN ACCORDANCE WITH GOOD ENGINEERING
PRACTICE IS SUFFICIENT.
Other Protective Equipment:NONE NORMALLY REQUIRED.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING AND BEFORE
EATING, DRINKING, OR SMOKING.
Supplemental Safety and Health
BTR VALVE SEALANTS INC WAS FORMERLY ROCKWELL INTERNATIONAL CORP. WITH
(STICK GRADE) IS FOR IDENTICAL PRODUCT PURCHASED FROM THE ROCKWELL
SEALANT (STICK GRADE). EACH HAS THE SAME NSN AND CAGE NO.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:MINERAL OIL
Other REC Limits:NONE SPECIFIED
OSHA PEL:5 MG/M3 (MIST)
Ingred Name:PETROLATUM
Other REC Limits:NONE SPECIFIED
OSHA PEL:5 MG/M3 (OIL MIST)
Ingred Name:LITHIUM HYDROXYSTEARATE
Other REC Limits:NONE SPECIFIED
Ingred Name:TREATED CLAY, (ORGANOPHILIC CLAY)
Other REC Limits:NONE SPECIFIED
Ingred Name:CALCIUM STEARATE
Fraction by Wt: 2-6%
Other REC Limits:NONE SPECIFIED
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: NEGLIGIBLE EFFECT. SKIN:
NEGLIGIBLE EFFECT. INHALATION: NONE EXPECTED. INGESTION: NEGLIGIBLE
EFFECT. MAY ACT AS LAXATIVE.
Effects of Overexposure:EYE IRRITATION.
Medical Cond Aggravated by Exposure:NONE KNOWN
* First Aid Measures *
First Aid:EYES: FLUSH WITH LARGE AMOUNT OF WATER. IF IRRITATION
PERSISTS GET MEDICAL ATTENTION. SKIN: WASH AREA WITH SOAP AND
WATER. INHALATION: VAPOR INHALATION IS NOT CONSIDERED A PROBLEM
UNDER NORMAL USAGE C ONDITIONS. INGESTION: IF SWALLOWED, DO NOT
INDUCE VOMITING. GET MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point Method:COC
Extinguishing Media:DRY CHEMICAL POWDER, CARBON DIOXIDE, CHEMICAL FOAM.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS WHEN
FIGHTING FIRE IN CONFINED AREAS.
Unusual Fire/Explosion Hazard:NONE KNOWN
* Accidental Release Measures *
Spill Release Procedures:RECOVER FREE MATERIAL. ADD SUITABLE ABSORBENT
TO SPILL AREA. CLEAN SPILL AREA WITH DETERGENT SOLUTION.
Neutralizing Agent:NONE
*Handling and Storage *
Handling and Storage Precautions:STORE IN SEALED CONTAINERS AWAY FROM
HEAT AND OXIDIZING MATERIALS.
Other Precautions:NONE
* Physical/Chemical Properties *
HCC:V6
Vapor Pres:NIL
Evaporation Rate & Reference:NIL
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CREAM-COLORED,GREASE-LIKE MATERIAL IN STICK
FORM.MILD HYDROCARBON OIL/SOAP ODOR
Percent Volatiles by Volume:NIL
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZERS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE AND
ASPHYXIANTS MAY BE PRODUCED FROM INCOMPLETE CONBUSTION.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF WASTE MATERIAL IN ACCORDANCE WITH
LOCAL, STATE AND FEDERAL REGULATIONS. IF PERMITTED, INCINERATE IN A
FURNACE.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NOT NORMALLY REQUIRED
Ventilation:NOT NORMALLY REQUIRED
Other Protective Equipment:CHEMICAL SPLASH APRON
Supplemental Safety and Health
SPECIAL PROTECTIVE EQUIPMENT SUFFICIENT TO PREVENT ALL SKIN CONTACT.
* Product Identification *
Product ID:DOUBLE BUBBLE RED/WHITE
Kit Part:Y
* Composition/Information on Ingredients *
Other REC Limits:NONE RECOMMENDED
Other REC Limits:NONE RECOMMENDED
Ingred Name:TRADESECRET
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: MAY CAUSE MOD SKIN/EYE IRRIT.
CHRONIC: NONE KNOWN
Medical Cond Aggravated by Exposure:PREEXISTING SKIN/EYE AILMENTS
* First Aid Measures *
MEDICAL AID. SKIN: REMOVE CONTAM CLOTHING AND WASH WITH SOAP AND
WATER. INHALATION: REMOVE TO FRESH AIR. INGESTION: IF APPRECIABLE
QUANTITI ES GET MED AID.
* Fire Fighting Measures *
Flash Point Method:COC
Lower Limits:NOT EST.
Upper Limits:NOT EST.
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:USE WATER FOG TO COOL FIRE EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:NONE KNOWN
* Accidental Release Measures *
Spill Release Procedures:DIKE TO PREVENT ENTRY TO SEWER/WATER SOURCES.
ABSORB & PLACE IN SUITABLE CONTAINER FOR DISPOSAL.
*Handling and Storage *
Handling and Storage Precautions:DO NOT STORE AT HIGH TEMPERATURES.
* Physical/Chemical Properties *
Appearance and Odor:CLEAR YELLOWISH LIQUID
Percent Volatiles by Volume:<0.1
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS
Stability Condition to Avoid:HIGH TEMPERTURES
Hazardous Decomposition Products:COX, NOX, SOX, AND ALDEHYDES
* Disposal Considerations *
Waste Disposal Methods:MAY BE INCINERATED OR PLACED IN LANDFILL IF
PERMITTED BY LOCAL REGS.
*
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR ON TEAROUT.
Ventilation:LOCAL VENTILATION SUFFICIENT TO KEEP DUST BELOW TLV'S.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:GOOD HOUSKEEPING AND GOOD HYGIENIC PRACTICES
SHOULD BE EMPLOYED.
Supplemental Safety and Health
* Product Identification *
Product ID:ADAMANT
CAGE:CRSNR
CAGE:CRSNR
* Composition/Information on Ingredients *
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
OSHA PEL:SEE TABLE Z3
Ingred Name:KAOLIN (HYDROUS ALUMINUM SILICATE/CLAY)
Ingred Name:SILICIC ACID (H*2SIO*3), DISODIUM SALT; (SODIUM SILICATE)
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:PRODUCT IS IN WET FORM, SO NOT
APPLICABLE UNTIL TEAROUT. DUST MAY IRRITATE THROAT, NASAL PASSAGES
AND UPPER RESPIRATORY TRACT. SKIN:MAY BE MILDLY IRRITATING TO SKIN.
EYES: MAY BE MILDLY IRRITATING TO THE EYES. MAY ABRADE EYES.
Explanation of Carcinogenicity:SILIC, CRYSTALLINE - QUARTZ:IARC
REPORT ON(SUPP DATA)
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INHAL: REMOVE TO DUST FREE AREA. SKIN: WASH AFFECTED AREA
MIN. SEEK MEDICAL ATTENTION. INGEST: GET MD IMMEDIATELY .
* Fire Fighting Measures *
Extinguishing Media:EXTINGUISHING MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:THIS PRODUCT IS NONFLAMMABBLE AND WILL
NOT SUPPORT COMBUSTION.
* Accidental Release Measures *
Spill Release Procedures:RETURN MATERIAL TO ORIGNIAL CONTAINER. COVER
AREA WITH AN ABSORBANT MATERIAL AS AREA WILL BE SLIPPERY. REMOVE
THE ABSORBANT AFTER A PERIOD OF TIME AND WASH AREA WITH WATER AND
SOAP.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
* Physical/Chemical Properties *
HCC:N1
Solubility in Water:MODERATE
Appearance and Odor:PINK PASTY MATL CONTAINING POWDER & AGGRAGATE
Percent Volatiles by Volume:0
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
GELS WHEN MIXED WITH ACID.
Stability Condition to Avoid:FLAMMABLE HYDROGEN GAS MAY BE PRODUCED ON
PROLONGED CONTACT WITH METALS SUCH AS ALUMINUM, TIN, LEAD AND ZINC.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
* Disposal Considerations *
Waste Disposal Methods:THE TEAROUT & DISPOSAL OF THIS PROD MAY GENERATE
DUST. DURING TEAROUT, OBSERVE THE EXPOSURE LIMITS OUTLINED IN
INGRED SECT, AND THE PERSONAL PROT PRECAUTIONS IN PERSONAL
PROTECTION INFORMATION SECTION . DISPOSAL SHALL BE I/A/W FED, STATE
& LOC REGS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN . NOT NORMALLY REQUIRED.
Ventilation:MAINTAIN OIL MISTS IN AIR BELOW EXPOSURE LIMIT BY PROCESS
DESIGN, ENCLOSURE, VENTILATION OR LOCAL EXTRACTION.
Other Protective Equipment:ANSI APPRVD EMER EYEWASH & DELUGE SHOWER .
NORMAL NON-SLIP INDUST FOOTWEAR. COVERALLS ARE NORMALLY SUFFICIENT.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
Product ID:SEASTAR STEERING FLUID
* Composition/Information on Ingredients *
Ingred Name:NON-HAZARDOUS INGREDIENTS
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE AND CHRONIC:NONE KNOWN.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:
* First Aid Measures *
DOCTOR IF IRRITATION PERSISTS. SKIN:WASH WITH SOAP AND WATER.
INGESTION:DO NOT INDUCE VOMITING. CALL A PHYSICIAN.
INHALATION:PRODUCT IS NOT VOLA TILE IN FORM SUPPLIED. REMOVE PERSON
TOFRESH AIR.
* Fire Fighting Measures *
Flash Point Method:COC
Extinguishing Media:CARBON DIOXIDE, FOAM, DRY CHEMICAL, HALON.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:HAZARDOUS COMBUSTION PRODUCTS:OXIDES OF
CARBON, SMOKE AND HYDROCARBONS.
* Accidental Release Measures *
Spill Release Procedures:PREVENT FROM ENTERING WATER SYSTEM. MOP UP,
SOAK UP, OR CONTAIN IN A CLOSED VESSEL.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:KEEP AWAY FROM INCOMPATIBLE
SUBSTANCES. DO NOT TAKE INTERNALLY. AVOID CONTACT WITH SKIN AND
EYES.
Other Precautions:STORE IN TIGHTLY CLOSED CONTAINERS.
* Physical/Chemical Properties *
Appearance and Odor:CLEAR YELLOW OIL WITH A FAINT ODOUR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:
Hazardous Decomposition Products:NONE KNOWN.
* Disposal Considerations *
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS . SEND TO A LICENSED RECLAIMER/WASTE DISPOSAL FACILITY,
INCINERATE OR LANDFILL TO MEET FEDERAL, PROVINCIAL AND LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF WORKPLACE EXPOS LIMIT OF PROD/ANY COMPONENT
IS EXCEEDED, A NIOSH/MSHA APPRVD AIR SUPPLIED RESP IS ADVISED IN
ABSENCE OF PROPER ENVIRONMENTAL CONTROL. OSHA REGS ALSO PERMIT
OTHER NIOSH/MSHA APPRVD R ESP UNDER SPECIFIED CNDTNS. (SUPP DATA)
Ventilation:MATERIAL MUST BE HANDLED OR TRANSFERRED IN AN APPROVED FUME
HOOD OR WITH EQUIVALENT VENTILATION.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. DO NOT TAKE
INTERNALLY. EYE WASH AND SAFETY EQUIPMENT SHOULD BE READILY
AVAILABLE.
Supplemental Safety and Health
RESP PROT:ENGINEERING &/OR ADMIN CONTROLS SHOULD BE IMPLEMENTED TO
REDUCE EXPOS. EFTS OF OVEREXP:TO EPINEPHRINE IN LAB ANIMALS & COULD
HAVE A SIMILAR EFT IN HUMANS. ADRENOMIMETICS (E.G., EPINEPHRINE)
MAY BE CONTRAINDICATED EXCEPT FOR LIFE-SUSTAINING USES IN HUMANS
ACUTELY/CHRONICALLY EXPOS TO CHLOROCARBONS
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:METHYLENE CHLORIDE (DICHLOROMETHANE)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:TOXIC BY INGESTION AND INHALATION.
IRRITATING ON CONTACT WITH SKIN, EYES OR MUCOUS MEMBRANES. MAY
CAUSE EYE INJURY. INHALALTION OF HIGH VAPOR CONCENTRATIONS CAUSES
DIZZINESS, NAUSEA, HEADACHE, NARCOSI S, IRREGULAR HEARTBEATS, COMA
AND DEATH. INGESTION MAY CAUSE IRRITATION OF THE GASTROINTESTINAL
TRACT (EFTS OF OVEREXP)
Explanation of Carcinogenicity:METHYLENE CHLORIDE. GROUP 2B (IARC);
GROUP 2 (NTP)
Effects of Overexposure:HLTH HAZ: W/VOMITING. IF VOMIT OCCURS,
METHYLENE CHLORIDE CAN BE ASPIR INTO LUNGS, WHICH CAN CAUSE CHEM
PNEUMONIA AND SYSTEMIC EFFECTS. EXCESSIVE EXPOSURE MAY CAUSE BLOOD
DEFECTS AND CAN AFFECT LIVER, KIDNEYS AND CNS. CHLOROCARBON MATLS
HAVE PRODUCED SENS OF THE MYOCARDIUM (SUPP DATA)
Medical Cond Aggravated by Exposure:HEART, KIDNEY AND LIVER CONDITIONS
* First Aid Measures *
First Aid:GET MEDICAL ASSISTANCE FOR ALL CASES OF OVEREXPOSURE. SKIN:
WASH THOROUGHLY WITH SOAP AND WATER. EYES: IMMEDIATELY FLUSH
AIR; GIVE ART IFICIAL RESPIRATION IF BREATHING HAS STOPPED. INGEST:
DO NOT INDUCE VOMITING; GET IMMEDIATE MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE AND DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED PRESSURE DEMAND SCBA
AND FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:FORMS FLAMMABLE VAPOR-AIR MIXTURES ABOVE
AMBIENT TEMPERATURES. THERMAL DECOMPOSITION PRODUCTS MAY INCLUDE
HCL & PHOSGENE .
* Accidental Release Measures *
Spill Release Procedures:DIKE SPILL; TAKE UP WITH ABSORBENT;
CONTAINERIZE FOR PROPER DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED. STORE
IN A COOL, WELL-VENT AREA AWAY FROM OPEN FLAMES. DO NOT BREATHE
VAPORS OR MIST. DO NOT GET IN EYES/SKIN/CLOTHING.
Other Precautions:EMPTY CNTNRS MAY BE HAZ DUE TO RETAINED RESIDUE; USE
CAUTION. NO SMOKING IN AREA OF USE. DO NOT USE IN THE GENERAL
VICINITY OF ARC WELDING/OPEN FLAMES/HOT SURFACES. HEAT &/OR UV
RADIATION MAY CAUSE TH E FORMATION OF HCL AND PHOSGENE .
* Physical/Chemical Properties *
HCC:T4
Solubility in Water:2 %
Appearance and Odor:COLORLESS LIQUID, ETHER-LIKE ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG BASES, STRONG OXIDIZERS, ALKALI METALS, AL, MG POWDER, NA, K,
AND LI.
Stability Condition to Avoid:CONTACT WITH OPEN FLAME, WELDING AREA, HOT
SURFACES.
Hazardous Decomposition Products:HCL, PHOSGENE, CHLORINE.
* Disposal Considerations *
Waste Disposal Methods:TO BE PERFORMED IN COMPLIANCE WITH ALL CURRENT
LOCAL, STATE AND FEDERAL REGULATIOINS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NOT NORMALLY REQUIRED. USE NIOSH APPROVED
RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:GOOD GENERAL VENT SHOULD BE SUFFICIENT FOR MOST CONDITIONS.
LOCAL EXHAUST VENT MAY BE NECESSARY FOR SOME OPERATIONS.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
Product ID:TRENDSETTER
Preparer's Name:THOMAS J. MITCHELL
* Composition/Information on Ingredients *
Ingred Name:DIETHYLENE GLYCOL MONOETHYL ETHER
Fraction by Wt: 5.0%
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:VAPORS MAY BE IRRITATING TO EYES AND
RESPIRATORY TRACT. MAY PRODUCE SYMPTOMS OF HEADACHE AND NAUSEA IN
POORLY VENTILATED AREAS.
Medical Cond Aggravated by Exposure:UNKNOWN.
* First Aid Measures *
First Aid:INHAL: REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE
OXYGEN/ARTIFICIAL RESPIRATION) . EYES: IN CASE OF CONTACT,
CONTACT LENSES. C ALL MD. SKIN: IN CASE OF SKIN CONTACT, FLUSH SKIN
WITH WATER. INGEST: IF SWALLOWED, DRINK LARGE QUANTITIES OF WATER;
CALL MD.
* Fire Fighting Measures *
Flash Point Method:TCC
Flash Point:NONE
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Unusual Fire/Explosion Hazard:NOT APPLICABLE.
* Accidental Release Measures *
Spill Release Procedures:SMALL SPILLS: FLUSH WITH WATER TO SEWER
SYSTEM. DIKE AND CONTAIN LARGE SPILLS WITH INERT MATERIAL AND
TRANSFER LIQUID TO CONTAINERS FOR RECOVERY OR DISPOSAL.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:KEEP FROM FREEZING.
Other Precautions:NONE.
* Physical/Chemical Properties *
pH:8.8-9
Evaporation Rate & Reference:<1 (BUT ACE=1)
Solubility in Water:COMPLETE
Appearance and Odor:TRANSLUCENT EMULSION; SLIGHT AMMONIACAL ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:
Hazardous Decomposition Products:NONE KNOWN.
* Disposal Considerations *
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH FEDERAL,
STATE AND LOCAL REGULATIONS . INCINERATION OR APPROVED LANDFILL.
* Regulatory Information *
SARA Title III Information:DIETHYLENE GLYCOL MONOETHYL ETHER
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:SCBA IN HIGH CONCENTRATIONS.
Ventilation:HANDLE UNDER COVERED EQUIPMENT.MECHANICAL (GENERAL)
VENTILATION RECOMMENDED.USE LOCAL EXHAUST IF VAPORS ESCAPE TO ROOM.
Other Protective Equipment:EYE BATH AND SAFETY SHOWER
Work Hygienic Practices:DO NOT BREATHE VAPORS.DO NOT GET IN EYES,SKIN
OR CLOTHING.WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
* Product Identification *
Product ID:CELLOSOLVE ACETATE
* Composition/Information on Ingredients *
Ingred Name:2-ETHOXYETHYL ACETATE (CELLOSOLVE ACETATE) (EGEEA)
Other REC Limits:5PPM
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:SEE SIGNS AND SYMPTOMS OF
HIGHER MAY CAUSE INJURY TO BONE MARROW AND BLOOD CELLS,KIDNEY,LIVER
AND TESTES.
Explanation of Carcinogenicity:IN LABORATORY ANIMALS INHALATION
STUDIES:BIRTH DEFECTS,INCREASED FETHAL LETHALITY,DELAYED FETAL
DEVELOPMENT.
Effects of Overexposure:EYES:IRRITATION;SKIN:SLIGHT
IRRITATION,DERMATITIS;SKIN ABSORPTION:SAME SYMPTOMS AS
INGESTION;INGESTION:HEADACHE,NAUSEA,VOMIT,DIZZINESS,WEAKNESS,POSSIB
LE KIDNEY DAMAGE;INHALATION:IRRITATION TO EYES,NOS E,RESPIRATORY
TRACT,HEADACHE,NAUSEA,VOMIT.VAPORS HAVE OBJECTIONABLE ODOR.
Medical Cond Aggravated by Exposure:RESPIRATORY AND SKIN AILMENTS.
* First Aid Measures *
First Aid:EYES:FLUSH WITH PLENTY OF WATER.SEE DOCTOR IF DISCOMFORT
PERSISTS;SKIN:REMOVE CONTAMINATED CLOTHING AND FLUSH SKIN WITH
WATER;INHALATION:REMOVE TO FRESH AIR.GIVE OXYGEN/CPR IF NEEDED.SEE
DOCTOR;INGEST ION:GIVE 2 GLASSES OF WATER.INDUCE VOMIT.SEE DOCTOR.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:1.7
Upper Limits:6.7
Extinguishing Media:WATER SPRAY,CO*2,DRY CHEMICAL,ALCOHOL TYPE OR
UNIVERSAL-TYPE FOAMS.
Fire Fighting Procedures:WEAR SCBA AND PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT.ABSORB IN INERT
MATERIAL AND PLACE IN APPROPRIATE DISPOSAL CONTAINER.
*Handling and Storage *
Handling and Storage Precautions:KEEP AWAY FROM HEAT AND FLAME.KEEP
CONTAINER CLOSED.
* Physical/Chemical Properties *
HCC:F4
Vapor Pres:2
Vapor Density:4.6
Appearance and Odor:WATER-WHITE LIQUID,MILD ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ALKALI METAL HYDROXIDES,SUCH AS SODIUM HYDROXIDE
Stability Condition to Avoid:IGNITION SOURCES
Hazardous Decomposition Products:CO,CO*2
* Disposal Considerations *
Waste Disposal Methods:INCINERATE IN A FURNACE WHERE PERMITTED UNDER
APPLICABLE FEDERAL,STATE AND LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NOT REQUIRED. NIOSH/MSHA APPROVED RESPIRATOR
APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:NOT REQUIRED.
Other Protective Equipment:NOT REQUIRED.
Work Hygienic Practices:CLEAN, SAFE WORK PRACTICES.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:TALC (POWDER), CONTAINING NO ASBESTOS FIBERS; (TALC)
OSHA PEL:0.2 FIBERS/CC
ACGIH TLV:0.2 FIBERS/CC
Ingred Name:CLAY (KAOLIN); (KAOLIN)
ACGIH TLV:2 MG/M3 TDUST
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE/CHRONIC: NONE KNOWN.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE KNOWN.
* First Aid Measures *
MD. SKIN: WASH THOROUGHLY WITH SOAP AND WATER. INGEST: DO NOT
INDUCE VOMITING. CONTACT A PHYSICIAN OR POISON CONTROL CENTER.
INHAL: REMOVE PERSON TO FRESH AIR.
* Fire Fighting Measures *
Flash Point:NONE
Lower Limits:NONE
Upper Limits:NONE
Extinguishing Media:WATER, FOAM, CO*2.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE KNOWN.
* Accidental Release Measures *
Spill Release Procedures:DIKE TO CONTAIN SPILL. KEEP OUT OF SEWERS AND
WATERCOURSES. ABSORB WITH INERT AND PLACE IN CONTAINER FOR
DISPOSAL. FLUSH RESIDUAL WITH COPIOUS AMOUNTS OF WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:STORE AT ROOM TEMPERATURE.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
* Physical/Chemical Properties *
Vapor Density:< 1
Spec Gravity:SUPP DATA
Evaporation Rate & Reference:< 1 (BU AC=1)
Solubility in Water:DISPERSES IN WATER
Appearance and Odor:VARIOUS COLORS, NO ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY PRODUCE
CARBON MONOXIDE AND CARBON DIOXIDE.
* Disposal Considerations *
Waste Disposal Methods:IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
Control Measures
*
Proprietary Ind: Y
*
Contractor Summary
*
*
Ingredients
*
-----------------------------
*
Health Hazards Data
*
*
Handling and Disposal
*
*
Fire and Explosion Hazard Information
*
Extinguishing Media: MEDIA SUITABLE FOR SURROUNDING FIRE (FP N). NOT A FIRE
HAZARD.
Fire Fighting Procedures: USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N).
*
*
*
Physical/Chemical Properties
*
PH: SUPDAT
Solubility in Water: SOLUBLE
Appearance and Odor: SMALL WHITE TABLET; NO ODOR.
*
Reactivity Data
*
Stability Indicator: YES
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
HAZCOM Label
*
Assigned IND: Y
Company Name: LAMOTTE CO
Street: UNKNOWN
Label Required IND: Y
Status Code: C
Origination Code: G
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE/CHRONIC:NONE LISTED BY MANUFACTURER.
*
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
VAPOR RESPIRATOR.
Ventilation:LOCAL EXHAUST: HOOD OR DUCT. MECHANICAL: FAN.
Other Protective Equipment:APPROPRIATE TO PREVENT PROLONGED CONTACT
WITH SKIN.
Work Hygienic Practices:TRAIN PERSONNEL IN SAFE HANDLING OF THIS
PRODUCT BEFORE USE.
Supplemental Safety and Health
* Product Identification *
Kit Part:Y
Preparer's Name:HERBERT MOORE
* Composition/Information on Ingredients *
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)
Other REC Limits:NONE SPECIFIED
Ingred Name:METHYL ISOBUTYL KETONE (SARA III)
Other REC Limits:NONE SPECIFIED
Other REC Limits:NONE SPECIFIED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE EYE, SKIN AND NOSE
IRRITATION. MAY LEAD TO MUSCULAR WEAKNESS AND DIZZINESS. LONG TERM
EXPOSURE MAY LEAD TO DERMATITIS, LIVER AND KIDNEY DAMAGE.
Effects of Overexposure:EYE, NOSE OR SKIN IRRITATION. HEADACHE AND
NAUSEA WITH IMPAIRED COORDINATION.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN DISORDERS,
RESPIRATORY TRACT: LIVER OR KIDNEY DISEASE.
* First Aid Measures *
First Aid:EYE CONTACT: FLUSH IMMEDIATELY WITH LARGE AMOUNTS OF WATER.
CONTACT PHYSICIAN. SKIN: WASH WITH MILD SOAP AND WATER.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:2.3
Extinguishing Media:DRY CHEMICAL, CO2, FOAM, WATER.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS IN
CONFINED AREAS.
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR AND CAN
TRAVEL TO SOURCES OF IGNITION.
* Accidental Release Measures *
Spill Release Procedures:REMOVE IGNITION SOURCES. TRANSFER TO SAFETY
CONTAINER, CLEAN UP REMAINDER WITH SAND OR SWEEPING COMPOUND. WASH
AREA WITH SOAP AND WATER.
*Handling and Storage *
Handling and Storage Precautions:STORE IN COOL, WELL-VENTILATED AREA.
GROUND CONTAINERS WHEN FILLING OR EMPTYING.
Other Precautions:WASH HANDS BEFORE EATING, DRINKING OR SMOKING AFTER
HANDLING THIS PRODUCT.
* Physical/Chemical Properties *
Melt/Freeze Pt:M.P/F.P Text:ROOM TEMP
pH:6.7
Evaporation Rate & Reference:5.7
Solubility in Water:MODERATE
Appearance and Odor:BLACK LIQUID, KETONE ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HIGH HEAT OR OPEN FLAME.
Hazardous Decomposition Products:CO2, H2S, CO, SO2.
* Disposal Considerations *
Waste Disposal Methods:REACT WITH CURING AGENT AND DISPOSE AS SOLID
HAZARDOUS WASTE ACCORDING TO FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
Control Measures
*
Product ID: NITROGEN (CALIBRATION GAS)
*
Contractor Summary
*
*
Ingredients
*
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
------------------------------
% Wt: <2 PPM
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: NOT ESTABLISHED
------------------------------
% Wt: <0.5PPM
Other REC Limits: NONE RECOMMENDED
------------------------------
% Wt: <0.5PPM
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: NO
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: TARGET ORGANS:EYE, SKIN, CNS, RESPIRATORY TRACT. ACUTE-
NITROGEN IS NONTOXIC BUT MAY PRODUCE SUFFOCATION BY DISPLACING OXYGEN. NO
HARMFUL EFFECT EXPECTED FROM VAPOR. LIQUID CAN CAUSE FROSTBITE. THIS P RODUCT
IS A GAS AT NORMAL TEMPERATURE AND PRESSURE. CANNOT BE SWALLOWED. CHRONIC-
NONE.
Explanation Of Carcinogenicity: NONE
Signs And Symptions Of Overexposure: LOSS OF BALANCE OR DIZZINESS; TIGHTNESS IN
THE FRONTAL AREA OF THE FOREHEAD; TINGLING OF THE TONGUE, FINGERTIPS OR TOES;
WEAKENED SPEECH LEADING TO THE INABILITY TO UTTER SOUNDS; RAPID REDUCTION IN
TH E ABILITY TO PERFORM MOVEMENTS; REDUCEDCONSCIOUSNESS OF SURROUNDINGS; LOSS
OF TACTILE SENSATIONS
Medical Cond Aggravated By Exposure: NONE
First Aid: PROMPT MEDICAL ATTENTION IS MANDATORY IN ALL CASES OF OVEREXPOSURE.
RESCUE PERSONNEL SHOULD WEAR SELF-CONTAINED BREATHING APPARATUS.
INHALED:REMOVE TO FRESH AIR. PROVIDE OXYGEN/CPR IF NEEDED. SKIN:TRE AT FOR
FROSTBITE. USE LUKEWARM WATER. DO NOT USE HOT WATER. EYES:CONSULT AN
OPHTHALMOLOGIST IMMEDIATELY.
*
Handling and Disposal
*
Spill Release Procedures: USE APPROPRIATE PROTECTIVE EQUIPMENT. EVACUATE ALL
PERSONNEL. VENTILATE AREA. IF LEAK IS IN CONTAINER OR CONTAINER VALVE,
Neutralizing Agent: NOT RELEVANT
Waste Disposal Methods: SLOWLY RELEASE INTO ATMOSPHERE OR RETURN IN THE
SHIPPING CONTAINER PROPERLY LABELED, WITH ANY VALVE OUTLET PLUGS OR CAPS
SECURED AND VALVE PROTECTION CAP IN PLACE. FOLLOW ALL LOCAL, STATE AND
FEDERAL REGULATIONS
Handling And Storage Precautions: STORE IN COOL, DRY, VENTILATED AREA BELOW
SECURED
Other Precautions: WASH HANDS AFTER HANDLING. NEVER CARRY A COMPRESSED GAS
CYLINDER IN AN ENCLOSED SPACE SUCH AS A CAR TRUNK, VAN OR STATION VAGON. USE
ONLY IN WELL VENTILATED AREA. DO NOT DRAG, SLIDE OR ROLL CYLINDERS. USE A
SUITABLE HAND TRUCK TO MOVE THEM.
*
Fire and Explosion Hazard Information
*
Flash Point Text: NONE
Extinguishing Media: USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY CHEMICAL FOR
SURROUNDING FIRE. NITROGEN CANNOT CATCH FIRE.
Fire Fighting Procedures: EVACUATE ALL PERSONNEL FROM DANGER AREA. IMMEDIATELY
DELUGE CONTAINERS WITH WATER SPRAY FROM MAXIMUM DISTANCE UNTIL COOL, THEN
MOVE CONTAINERS AWAY IF NO RISK.
Unusual Fire/Explosion Hazard: CYLINDERS MAY RUPTURE DUE TO HEAT OF FIRE. NO
*
*
Respiratory Protection: NONE NORMALLY REQUIRED. IN EMERGENCIES, WEAR A
NIOSH-APPROVED POSITIVE PRESSURE AIR LINE WITH MASK OR SELF-CONTAINED
BREATHING APPARATUS.
Ventilation: LOCAL EXHAUST
Other Protective Equipment: SAFETY SHOES
Work Hygienic Practices: OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES.
Supplemental Safety and Health: NONE
*
Physical/Chemical Properties
*
HCC: G3
NRC/State LIC No: NOT RELEVANT
Spec Gravity: NOT RELEVANT
Evaporation Rate & Reference: NOT RELEVANT
Solubility in Water: VERY SLIGHT
Appearance and Odor: COLORLESS, ODORLESS GAS
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: EXCESSIVE HEAT
Materials To Avoid: NONE
Hazardous Decomposition Products: NONE
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
Transportation Information
*
Product ID: NITROGEN (CALIBRATION GAS)
Multiple KIT Number: 0
Review IND: Y
*
Detail DOT Information
*
DOT PSN Code: KLZ
DOT Proper Shipping Name: NITROGEN, COMPRESSED
Hazard Class: 2.2
Label: NONFLAMMABLE GAS
Vessel Stow Req: A
*
Detail IMO Information
*
IMO PSN Code: KSR
IMO Proper Shipping Name: NITROGEN, COMPRESSED
UN Hazard Class: 2(2.2)
IMO Packaging Group: -
Subsidiary Risk Label: -
MED First Aid Guide NUM: NON
*
Detail IATA Information
*
IATA PSN Code: SBP
IATA Proper Shipping Name: NITROGEN, COMPRESSED
IATA UN Class: 2.2
IATA Label: NON-FLAMMABLE GAS
*
Detail AFI Information
*
AFI PSN Code: SBP
AFI Proper Shipping Name: NITROGEN, COMPRESSED
AFI Hazard Class: 2.2
Special Provisions: P5
Back Pack Reference: A6.3, A6.6
*
HAZCOM Label
*
Product ID: NITROGEN (CALIBRATION GAS)
Company Name: LIQUID AIR CORPONE CALIFORNIA PLAZA
Label Required IND: Y
Status Code: C
Origination Code: F
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Slight
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: SPILL: USE APPROPRIATE PROTECTIVE EQUIPMENT. EVACUATE
ALL PERSONNEL. VENTILATE AREA. IF LEAK IS IN CONTAINER OR CONTAINER VALVE,
PROMPT MEDICAL ATTENTION IS MANDATORY IN ALL CASES OF OVEREXPOSURE. RESCUE
PERSONNEL SHOULD WEAR SELF-CONTAINED BREATHING APPARATUS. INHALED:REMOVE TO
FRESH AIR. PROVIDE OXYGEN/CPR IF NEEDED. SKIN:TR EAT FOR FROSTBITE. USE
LUKEWARM WATER. DO NOT USE HOT WATER. EYES:CONSULT AN OPHTHALMOLOGIST
IMMEDIATELY.
*
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH APPROVED RESPIRABLE FUME RESPIRATOR OR
AIR SUPPLIED RESPIRATOR WHEN WELDING IN CONFINED SPACE OR GENERAL
WORK AREA WHERE LOCAL EXHAUST AND/OR VENTILATION DOES NOT KEEP
EXPOSURE BELOW THE THR ESHOLD LIMIT VALUE.
Ventilation:USE PLENTY OF VENT &/OR LOC EXHST AT ARC TO KEEP FUMES &
GASES BELOW TLV W/IN WORKER'S BRTHG ZONE & GEN WORK AREA.
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER . ARM
PROTECTORS, APRON, HATS, SHOULDER PROT & DARK SUBSTANTIAL CLTHG.
Work Hygienic Practices:TRAIN WELDER NOT TO ALLOW ELEC LIVE PARTS TO
GROUND.
Supplemental Safety and Health
HAZ DECOMP PRODS: WELDED, PROCS FOLLOWED & ELECTRODES USED. REASONABLE
EXPECTED FUME CONSTITUENTS OF PROD WOULD INCL: COMPLEX OXIDES OF
ALUMINUM, IRON, MANGANESE, SILICON, TITANIUM, CHROMIUM, NICKEL,
CALCIUM, COLUMBIAN, MOLYBDENUM & COPPER. FLUORIDES WILL ASLO BE
* Product Identification *
CAGE:0AZS7
* Composition/Information on Ingredients *
Ingred Name:IRON
OSHA PEL:N/K
ACGIH TLV:N/K
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3
Ingred Name:MOLYBDENUM
OSHA PEL:5 MG/M3 DUST, C
ACGIH TLV:5 MG/M3 DUST
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SILICON
Ingred Name:NIOBIUM; (COLUMBIUM)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:TITANIUM DIOXIDE
Ingred Name:CALCIUM CARBONATE
Ingred Name:CALCIUM FLUORIDE
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SODIUM SILICATE
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CLAY (KAOLIN); (ALUMINUM SILICATES)
ACGIH TLV:2 MG/M3 TDUST
Ingred Name:POTASSIUM SILICATES
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CRYOLITE
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ZIRCONIUM SILICATES
OSHA PEL:N/K
ACGIH TLV:N/K
OSHA PEL:0.1MG/M3 FUME;1 DUST
ACGIH TLV:0.2 MG/M3 FUME
Ingred Name:SILICA, CRYSTALLINE - QUARTZ; (QUARTZ)
OSHA PEL:N/K
ACGIH TLV:0.1 MG/M3 RDUST
Ingred Name:SUPDAT: BE REACHED BEFORE LIM OF 5 MG/M3 FOR GEN WELDING
FORMED BY RADIA FROM ARC. CONTACT NEHC FOR MORE INFO .
Ingred Name:EFTS OF OVEREXP: IN LUNG) & IS BELIEVED TO AFFECT PULM
RAYS CAN INJURE EYES & BURN SKIN. ELEC SHOCK CAN KILL.
Ingred Name:EYE PROT:& FULL LNGTH FSHLD W/FILTER LENS SHADE
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE OVEREXP TO WELDING FUMES MAY
RSLT IN DISCOMFORT SUCH AS DIZZ, NAUS OR DRYNESS/IRRIT OF NOSE,
THROAT/EYES. INHAL OF EXTREMELY HIGH LEVELS OF FLUORIDES MAY CAUSE
ABDOM PAIN, DIARR, MUSC WEAK & CON VLS. CONTINUED INHAL COULD CAUSE
UNCON & DEATH. CHROMIUM (VI) CMPDS PRESENT IN FUME MAY CAUSE SEV
IRRIT(EFTS OF OVEREXP)
Effects of Overexposure:HLTH HAZ: OF BRONCH TUBES & LUNGS. INGEST OF
CHROMIUM (VI) SALTS MAY CAUSE INJURY/DEATH. CHROMIUM(VI) CMPDS MAY
BURN EYES. CHROMIUM CMPDS MAY CAUSE ALLERGIC RXNS. NICKEL OXIDES IN
FUME MAY CAUSE TIGHT NESS AROUND CHEST, FEVER & ALLERGIC RXNS.
CHRONIC OVEREXP TO WELDING FUMES CAN LEAD TO SIDEROSIS (IRON
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INGEST: CALL MD IMMED . EYES: IMMED FLUSH W/POTABLE WATER FOR
W/COPIOUS AMTS OF WATER. CALL MD . CALL FOR MED ASSISTANC E. USE
FIRST AID PROCEDURERS RECOM BY AMERICAN RED CROSS. IF BREATHING IS
DFCLT, GIVE OXYGEN. IF NOT BREATHING USE CPR. CONSULT MD IF
IRRITATION OF EYES & SKIN OR FLASH BURNS DEVELOP AFTER EXPOSURE.
* Fire Fighting Measures *
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NON-FLAMMABLE: WELDING ARC AND SPARKS CAN
* Accidental Release Measures *
Spill Release Procedures:NONE SPECIFIED BY MANUFACTURER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:READ & UNDERSTAND MFR'S INSTRUCTIONS &
PREC LABEL ON PROD. ADVISE WELDERS TO KEEP THEIR HEAD OUT OF FUMES.
Other Precautions:ONE METHOD OF DETERMINING COMPOSITION & QTY OF FUMES
& GASES TO WHICH WORKERS ARE EXPOSED IS TO TAKE AIR SAMPLE FROM
INSIDE WELDER'S HELMET WHILE WORN OR IN WORKER'S BREATHING ZONE.
SEE ANSI/AWS F1.1 AVAIL FROM AMERICAN WELDING SOCIETY.
* Physical/Chemical Properties *
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:WELDING FUMES & GASES CANNOT BE
CLASSIFIED SIMPLY. COMPOSITION & QTY OF FUMES & GASES DEPEND ON
METAL BEING (SUPDAT)
* Disposal Considerations *
Waste Disposal Methods:DISCARD ANY PRODUCT, RESIDUE, DISPOSAL CONTAINER
OR LINER IN AN ENVIRONMENTALLY ACCEPTABLE MANNER APPROVED BY
FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NOT NORMALLY NEEDED UNLESS MATERIAL BECOMES
AIRBORNE.
Ventilation:NOT NORMALLY NEEDED.
Other Protective Equipment:APRON, RUBBER BOOTS.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:POTASSIUM HYDROXIDE, KOH
Other REC Limits:2 MG/CUM (CEILING)
ACGIH TLV:2 MG/CUM (CEILING)
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: SEVERE BURNS TO TISSUE/DAMAGE.
INGESTION/INHALATION: CAUSES SEVERE DAMAGE TO INTERNAL ORGANS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:BURNS.
* First Aid Measures *
First Aid:INGESTION: DRINK LARGE AMOUNTS OF WATER/MILK, FOLLOWED BY
DILUTE VINEGAR/FRUIT JUICE. SKIN: WASH W/LARGE AMOUNTS OF WATER 1-2
OBTAIN MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Extinguishing Media:NON FLAMMABLE
* Accidental Release Measures *
Spill Release Procedures:DISSOLVE, DILUTE & FLUSH AWAY W/ABUNDANT
WATER. DILUTE ACID, PREFERABLY ACETIC ACID MAY BE USED TO
NEUTRALIZE TRACES OF CAUSTIC AFTER FLUSHING W/WATER. SODIUM
BICARBONATE MAY THEN BE USED FOR FINAL NE UTRALIZATION.
*Handling and Storage *
Handling and Storage Precautions:LIQUID POTASH SHOULD BE STORED ABOVE
FREEZING POINT.
* Physical/Chemical Properties *
HCC:C2
Appearance and Odor:CLEAR LIQUID; ODORLESS
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ALUMINUM, LEATHER, WOOL, TIN, ZINC, ALLOYS, STRONG ACIS.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.DON'T DISCHARGE INTO STREAMS/SEWERS. CAUSTIC POTASH
SHOULD BE CONVERTED TO NEUTRAL SALT AS BY NEUTRALIZATION W/ACID,
THEN WELL DILUTED W/WATER.
| 1 | eyes_protection_mandatory |
Control Measures
*
Cage: 1F3R7
*
Contractor Summary
*
Cage: 1F3R7
*
Ingredients
*
Percent by Wt: 8.
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE: IRRITATING TO UPPER RESPIRATORY TRACT, SKIN AND
EYES. INGESTION OF LARGE QUANTITIES MAY CAUSE GASTROINTESTINAL IRRITATION.
CHRONIC: HIGH BLOOD PRESSURE, RAPID INEFFECTIVE BREATHING. TARGET ORGA NS:
EYES, SKIN, RESPIRATORY SYSTEM, MUCOUS MEMBRANES.
Signs And Symptions Of Overexposure: MATERIAL CAN CAUSE IRRITATION TO SKIN,
EYES, MUCOUS MEMBRANES AND/OR UPPER RESPIRATORY TRACT.
Medical Cond Aggravated By Exposure: CAN AGGRAVATE PRE-EXISTING MEDICAL
CONDITIONS SUCH AS HIGH BLOOD PRESSURE.
First Aid: INGESTION: WASH OUT MOUTH WITH WATER. CONTACT MD IMMEDIATELY.
INHALATION: REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE ARTIFICIAL
RESPIRATION. IF BREATHING IS DIFFICULT, GIVE OXYGEN. SKIN: REMOVE CONTA
MINATED CLOTHING AND SHOES. WASH SKIN WITH SOAP AND COPIOUS AMOUNTS OF WATER.
EYES: IMMEDIATELY FLUSH EYES AND UNDER EYELIDS WITH COPIOUS AMOUNTS OF WATER
*
Handling and Disposal
*
Spill Release Procedures: WEAR SUITABLE PROTECTIVE CLOTHING. CAREFULLY SWEEP UP
AND REMOVE.
Waste Disposal Methods: DISPOSE OF I/A/W ALL APLICABLE FEDERAL, STATE AND LOCAL
ENVIRONMENTAL REGULATIONS.
Handling And Storage Precautions: STORE IN A TIGHTLY CLOSED CONTAINER IN A
COOL, DRY PLACE. USE ONLY IN AREAS WITH ADEQUATE VENTILATION.
*
Fire and Explosion Hazard Information
*
Extinguishing Media: USE EXTINGUISHING MEDIA APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA AND FULL PROTECTIVE EQUIPMENT
(FP N).
Unusual Fire/Explosion Hazard: EMITS TOXIC FUMES OF HYDROGEN CHLORIDE.
*
*
Respiratory Protection: NIOSH APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF
CONCERN (FP N).
Ventilation: USE ONLY IN AREAS WITH ADEQUATE VENTILATION.
Other Protective Equipment: EYE WASH & DELUGE SHOWER MEETING ANSI DESIGN
CRITERIA (FP N). LAB COAT IS RECOMMENDED, WHILE HANDLING.
*
Physical/Chemical Properties
*
Vapor Pres: <1 MM HG
Vapor Density: N/A(AIR=1)
Evaporation Rate & Reference: N/A (BUTYL ACETATE=1)
Appearance and Odor: WHITE CRYSTALLINE SOLID.
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: CONTACT WITH INCOMPATIBLE MATERIALS.
Materials To Avoid: STRONG OXIDIZING AGENTS, LITHIUM, INTER-HALOGENS (EX.
BROMINE TRIFLUORIDE), IRON, CEMENT.
Hazardous Decomposition Products: TOXIC FUMES OF HYDROGEN CHLORIDE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: WILL NOT OCCUR.
*
Toxicological Information
*
AVAILABLE.
*
Other Information
*
*
HAZCOM Label
*
Cage: 1F3R7
Company Name: INVITROGEN CORPORATION (U.S. HEADQUARTERS)
Label Required IND: Y
Status Code: A
Origination Code: F
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE: IRRITATING TO UPPER RESPIRATORY TRACT, SKIN AND
EYES. INGESTION OF LARGE QUANTITIES MAY CAUSE GASTROINTESTINAL IRRITATION.
CHRONIC: HIGH BLOOD PRESSURE, RAPID INEFFECTIVE BREATHING. TARGET ORGA NS:
EYES, SKIN, RESPIRATORY SYSTEM, MUCOUS MEMBRANES.
*
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR NIOSH APPROVED INDUSTRIAL CANNISTER TYPE
GAS MASK.
Ventilation:LOCAL EXHAUST
Other Protective Equipment:PLASTIC APRON
Supplemental Safety and Health
* Product Identification *
Product ID:CMA-GTO LIQUID SSS-SPOT SOLVENT
CAGE:CLAUS
* Composition/Information on Ingredients *
Ingred Name:METHYL CHLOROFORM (1,1,1-TRICHLOROETHANE) (CHLOROTHENE NU),
AEROTHANE TT, CHLOROTHENE
Ozone Depleting Chemical:1
Ingred Name:PERCHLOROETHYLENE (TETRACHLOROETHYLENE) (2B ANIMAL
CARCINOGEN BY NTP)
Ingred Name:TOLUENE
Fraction by Wt: 3%
Ingred Name:ISOPROPANOL (ISOPROPYL ALCOHOL), 2-PROPANOL, DIMETHYL
CARBINOL
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:NO OSHA:YES
Health Hazards Acute and Chronic:INHALATION: VOMITING, UNCONSCIOUSNESS,
DEATH, ELEVATED CARBOXYHEMOGLOBIN LEVELS, HEADACHE, MENTAL
DEPRESSION, CONFUSION, FATIGUE, LOSS OF APPETITE, NAUSEA, LOSS OF
BALANCE, & IRRITATION TO RESPIRATORY TRACT.
Explanation of Carcinogenicity:PERCHLORETHANE IS A SUSPECTED 2B ANIMAL
CARCINOGEN.
Effects of Overexposure:INHALATION: VOMITING, UNCONSCIOUSNESS, DEATH,
ELEVATED CARBOXYHEMOGLOBIN LEVELS, HEADACHE, MENTAL DEPRESSION,
CONFUSION, FATIGUE, LOSS OF APPETITE, NAUSEA, LOSS OF BALANCE, &
IRRITATION TO RESPIRATORY TRACT.
* First Aid Measures *
& WATER. A SOOTHING OINTMENT MAY BE APPLIED AFTER CLEANING.
INGESTION: DON'T INDUCE VOMITING. POSITION HEAD TO KEEP AIRWAYS
CLEAR. INHALAT ION: REMOVE TO FRESH AIR. IF BREATHING HAS STOPPED,
ARTIFICIAL RESPIRATION SHOULD BE STARTED, OXYGEN MAY BE
ADMINISTERED. OBTAIN MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:8%
Extinguishing Media:FOAM, CO2, OR DRY CHEMICALS
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS IF IN
BUILDINGS OR CONFINED AREAS.
Unusual Fire/Explosion Hazard:CONTENTS UNDER PRESSURE. EXPOSURE TO
* Accidental Release Measures *
Spill Release Procedures:UNLIKELY, SINCE THIS IS AN AEROSOL.
*Handling and Storage *
Handling and Storage Precautions:DON'T PUNCTURE, INCINERATE, OR STORE
* Physical/Chemical Properties *
Vapor Density:-4.3
Solubility in Water:1.3%
Appearance and Odor:CLEAR LIQUID W/STRONG CLEANING FLUID ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXYGEN, ALKALI METALS
Hazardous Decomposition Products:HYDROGEN CHLORIDE VAPOR & SMALL
AMOUNTS OF OTHER TOXIC VAPORS SUCH AS PHOSGENE
* Disposal Considerations *
Waste Disposal Methods:REPLACE CAP & DISCARD CONTAINER IN TRASH. DON'T
INCINERATE OR PUNCTURE.
| 1 | eyes_protection_mandatory |
Control Measures
*
Kit Part: Y
Proprietary Ind: Y
*
Contractor Summary
*
*
Ingredients
*
-----------------------------
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE:SKIN CONTACT MAY CAUSE IRRITATION. EYE CONTACT
CAUSES IRRITATION, REDNESS, TEARING & BLURRED VISION. CHRONIC:RPTD EXPOS
CAN CAUSE ALLERGIC RXN W/DEVELOPMENT OF OCCUP ASTHMA. LONG TERM RPTD EXPOS
TO LOW VAP LEVELS CAN CAUSE CHRONICALLY PROGRESSIVE PULM DISEASE. RPTD SKIN
CONTACT CAN RESULT IN SENSIT.
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
POSSIBLE. SKIN:WASH W/SOAP & WATER & REMOVE CONTAMINATED CLOTHING.
INGEST:SEE MD IMMEDIATELY. INHAL:REMOVE TO FRESH AIR. SUPPORT BREATHIN G
(GIVE O*2/ARTF RESP) (FP N).
*
Handling and Disposal
*
Spill Release Procedures: IN ENCLSD AREAS, CLEANUP PERS SHLD WEAR NIOSH/MSHA
APPRVD SCBA. COVER SPILLS W/SAWDUST, VERMICULITE/OTHER ABSORB MATL TO MIN
SPREADING OF MATL BEFORE COLLECTING.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE I/A/W LOCAL, STATE & FEDERAL REGULATIONS.
Handling And Storage Precautions: KEEP CONTAINERS CLOSED & STORE IN COOL
DRY PLACE AWAY FROM DIRECT SUNLIGHT. HARMFUL OR FATAL IF SWALLOWED. VAPOR
HARMFUL.
Other Precautions: MAY CAUSE SKIN OR EYE IRRITATION. KEEP OUT OF REACH OF
CHILDREN.
*
Fire and Explosion Hazard Information
*
Flash Point Text: NON-FLAMMABLE
Extinguishing Media: FOAM, CO*2, DRY CHEMICAL OR WATER FOG.
Fire Fighting Procedures: WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP (FP
N). DO NOT SPRAY POOL FIRES DIRECTLY; SOLID STREAM OF H*2O DIRECTED INTO HOT,
BURNING LIQ CAN CAUSE FROTHING.
Unusual Fire/Explosion Hazard: ADHESIVE COMPONENTS ARE NON-FLAMMABLE & WILL
NOT EXPLODE FROM MECHANICAL IMPACT.
*
*
Respiratory Protection: USE NIOSH/MSHA APPROVED ORGANIC VAPOR CARTRIDGES
W/MECHANICAL FILTER TO REMOVE AIRBORNE PARTICLES. USE NIOSH/MSHA APPROVED
SCBA IN ENCLOSED AREAS.
Ventilation: MECHANICAL VENTILATION.
Other Protective Equipment: EYE BATH & SAFETY SHOWER SHOULD BE AVAILABLE.
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: NONE SPECIFIED BY MANUFACTURER.
*
Physical/Chemical Properties
*
B.P. Text: SEE ING 3
Vapor Pres: SEE ING
Vapor Density: LTR/AIR
Spec Gravity: 1 (FP N)
Evaporation Rate & Reference: SLOWER THAN ETHER
Appearance and Odor: LIQUID
Percent Volatiles by Volume: NIL
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: TEMPERATURE EXTREMES.
Materials To Avoid: NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products: INCOMPLETE BURNING MAY PRODUCE NITROGEN
OXIDES, HYDROGEN CYANIDE, CO &/OR CO*2.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
Transportation Information
*
Multiple KIT Number: 0
Kit Part IND: Y
Review IND: Y
Additional Data: NOT REGULATED FOR TRANSPORTATION
*
Detail DOT Information
*
DOT PSN Code: ZZZ
DOT Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
*
Detail IMO Information
*
IMO PSN Code: ZZZ
IMO Proper Shipping Name: NOT REGULATED FOR THIS MODE OF TRANSPORTATION
*
Detail IATA Information
*
IATA PSN Code: ZZZ
IATA Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
*
Detail AFI Information
*
AFI PSN Code: ZZZ
AFI Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
*
HAZCOM Label
*
Company Name: GACO WESTERN INC
Label Required IND: Y
Status Code: C
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Slight
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE:SKIN CONTACT MAY CAUSE IRRITATION. EYE CONTACT
MAY CAUSE IRRITATION, REDNESS, TEARING AND BLURRED VISION. CHRONIC:REPEATED
EXPOSURE CAN CAUSE ALLERGIC REACTION, DEVELOPMENT OF OCCUPATIONAL ASTHM A,
CHRONICALLY PROGRESSIVE PULMONARY DISEASE AND SKIN SENSITIZATION.
*
| 1 | eyes_protection_mandatory |
Control Measures
*
Cage: OFTT5
*
Preparer Co. when other than Responsible Party Co.
*
Cage: OFTT5
Assigned Ind: Y
*
Contractor Summary
*
Cage: OFTT5
*
Item Description Information
*
Item Manager: GSA
Item Name: CLEANING COMPOUND,SOLVENT-DETERGENT
Unit of Issue: DR
UI Container Qty: 1
*
Ingredients
*
% Wt: <8.0
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: NOT ESTABLISHED
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: NO
Skin: NO
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Signs And Symptions Of Overexposure: CHRONIC CONTACT W/SKIN MAY CAUSE
DEFATTING, REDNESS, IRRITATION.
Medical Cond Aggravated By Exposure: UNKNOWN
First Aid: SKIN/CLOTHES: WASH W/SOAP & WATER. WASH CLOTHES BEFORE REUSE.
LARGE AMOUNTS WATER/MILK. GET IMMEDIATE MED AID.
*
Handling and Disposal
*
Spill Release Procedures: PICK UP SPILL W/ABSORBENT MATERIAL & SWEEP UP.
FLUSH AREA W/WATER. CAUTION: FLOORS MAY BE SLIPPERY. TAKE CARE TO AVOID
FALLS.
Waste Disposal Methods: IN ACCORDANCE W/FEDERAL, STATE, LOCAL REGULATIONS.
Handling And Storage Precautions: KEEP AWAY FROM CHILDREN! STORE IN DRY, COOL
PLACE. DO NOT CONTAMINATE FOOD, FEED OR WATER.
Other Precautions: DO NOT INEGEST. USE WITH ADEQUATE VENTILATION. AVOID
PROLONGED CONTACT WITH SKIN. DO NOT GET IN EYES. ALWAYS MAINTAIN TLV.
*
Fire and Explosion Hazard Information
*
Lower Limits: NA
Upper Limits: NA
Extinguishing Media: WATER SPRAY OR FOG, DRY CHEMICAL, CO2 OR ALCOHOL FOAM IF
PRODUCT INVOLVED IN FIRE.
Fire Fighting Procedures: USE NIOSH/MSHA APPROVED SCBA WHERE PRODUCT INVOLVED
IN FIRE. KEEP FIRE-EXPOSED CONTAINERS COOL W/WATER SPRAY TO PREVENT BURSTING.
Unusual Fire/Explosion Hazard: THIS PRODUCT WILL NOT BURN. EXTREME HEAT MAY
CAUSE BURSTING OF CONTAINER AND DECOMPOSITION OF MATERIAL.
*
*
Respiratory Protection: NONE W/NORMAL VENTILATION
Ventilation: NA
Other Protective Equipment: NA
Work Hygienic Practices: USE GOOD PERSONAL HYGIENE. WASH HANDS AFTER HANDLING,
BEFORE EATING.
*
Physical/Chemical Properties
*
M.P/F.P Text: NOT EST.
Vapor Density: 1.0
PH: 8.0
Viscosity: WATER-LIKE
Evaporation Rate & Reference: 1 (WATER=1)
Solubility in Water: COMPLETE
Appearance and Odor: CLEAR, GREEN COLORED LIQUID, PLEASANT SASSAFRAS ODOR
Corrosion Rate: NA
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: NA
Materials To Avoid: NA
Hazardous Decomposition Products: NORMAL COMBUSTION PRODUCTS FROM BURNING,
CARBON DIOXIDE & CARBON MONOXIDE.
Hazardous Polymerization Indicator: NO
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
Transportation Information
*
Multiple KIT Number: 0
Review IND: Y
Unit Of Issue: DR
Container QTY: 1
*
Detail DOT Information
*
DOT PSN Code: ZZZ
DOT Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
*
Detail IMO Information
*
IMO PSN Code: ZZZ
IMO Proper Shipping Name: NOT REGULATED FOR THIS MODE OF TRANSPORTATION
*
Detail IATA Information
*
IATA PSN Code: ZZZ
IATA Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
*
Detail AFI Information
*
AFI PSN Code: ZZZ
AFI Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
*
HAZCOM Label
*
Cage: OFTT5
Assigned IND: Y
Company Name: LHB INDUSTRIES
Label Required IND: Y
Status Code: A
Origination Code: G
*
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:A RESPIRATOR IS NOT REQUIRED UNDER NORMAL
CONDITIONS OF USE IF EXPOSURE LIMITS ARE KEPT BELOW ESTABLISHED
LIMITS. IN THE EVENT THAT RESPIRATORY PROTECTION IS REQUIRED, A
NIOSH APPROVED ACID-RESISTANT RESPIRATOR MUST BE USED.
Ventilation:ADEQUATE LOCAL AND/OR GENERAL EXHAUST VENTILATION OR OTHER
ENGINEERING CONTROLS TO KEEP AIRBORNE CONCENTRATIONS BELOW EXPOSURE
LIMITS.
ON (WORK HYGIENE)
.
Other Protective Equipment:READILY ACCESSIBLE EYEWASH FACILITY AND
QUICK DRENCH SAFETY SHOWER MEETING ANSI DESIGN CRITERIA. DEPENDING
ON OPERATION, LABCOAT, APRON OR OTHER IMPERMEABLE CLOTHING MAY BE
APPROPRIATE.
Work Hygienic Practices:CLEAN CONTAMINATED CLOTHING BEFORE REUSE, OR
GOOD PROTECTION (SUPP SAFETY)
Supplemental Safety and Health
GOOD RESISTANCE: POLYVINYL CHLORIDE, POLYETHYLENE, NITRILE &
POLYVINYL C HLORIDE, NEOPRENE, VITON & BUTYL RUBBER. POLYVINYL
* Product Identification *
Kit Part:Y
* Composition/Information on Ingredients *
Ingred Name:HYDROCHLORIC ACID. (SYNONYM: HYDROGEN CHLORIDE)
OSHA PEL:C7 MG/M3;C5 PPM
ACGIH STEL:C7.5 MG/M3;C5 PPM
Ingred Name:WATER
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PERTAINS TO EFFECTS ASSOCIATED WITH
AQUEOUS SOLUTIONS OF HYDROCHLORIC ACID. ACUTE: INHAL: CORROSIVE TO
TISSUES OF MUCOUS MEMBRANES, UPPER RESPIRATORY TRACT. AFTER SHORT
INHALATIONMAY BE FATAL AS RESULT OF SPASM, INFLAMMATION & FLUID
BUILD-UP IN LARYNX, BRONCHI & LUNG, & LUNG INFLAMMATION.
INGESTION: CORROSIVE TO MUCOUS MEMBRANES OF M OUTH, THROAT,
ESOPHAGUS, & STOMACH. CIRCULATORY COLLAPSE & DEATH MAY OCCUR. SKIN:
CORROSIVE TO SKIN. EYE: EXTREMELY DESTRUCTIVE TO EYES. IRRITATION,
PERMANENT VISUAL DAMAGE (INCLUDING LOSS OF VISION)MAY OCCUR.
(SIGNS/SYMP OF OVEREXPOSURE).
Explanation of Carcinogenicity:HYDROCHLORIC ACID IS NOT LISTED AS
CARCINOGENIC BY NTP, IARC OR OSHA. NO HUMAN DATA AVAILABLE. IN
ANIMAL DATA REPORTED IN LITERATURE, HYDROCHLORIC ACID WAS NOT FOUND
TO BE CARCINOGENIC. HOWEVER, THIS COMPOUND IS REPORTED TO BE
MUTAGENIC IN MAMMALIAN & BACTERIAL TEST SYSTEMS.
Effects of Overexposure:INHALATION: BURNING SENSATION, COUGHING,
WHEEZING, SNEEZING, LARYNGITIS, SHORTNESS OF BREATH, HEADACHE,
NAUSEA, & VOMITING. INGESTION: DIFFICULTY SWALLOWING, NAUSEA,
VOMITING, INTENSE THIRST, DIARRHEA , INFLAMMATION OF KIDNEYS,
CHILLS, AND SHOCK. SKIN: BURNING, IRRITATION OR RASH & INCREASED
SENSITIVITY OF THE SKIN TO SUNLIGHT. EYE: IRRITATION & PERMANENT
VISION DAMAGE. HEALTH HAZARD ACUTE/CHRONIC (CONT'D): TARGET
ORGANS: RESPIRATORY SYSTEM, SKIN, & EYES. CHRONIC:
CHRONIC/PROLONGED EXPOS MAY RESULT IN CHANGES IN LUNG FUNCTION,
CHRONIC BRONCHITIS, DERMATITIS, DIGEST DISEASES (CHARACTERIZED BY E
ROSION OF DENTAL ENAMAL), (OTHER INFO)
Medical Cond Aggravated by Exposure:PERSONS WITH IMPAIRED LUNG FUNCTION
MAY BE AT INCREASED RISK FROM EXPOSURE TO HYDROCHLORIC ACID.
* First Aid Measures *
First Aid:INHAL: REMOVE TO FRESH AIR. IF NOT BRTHG, PERFOM ARTF RESP.
IF BRTHG DFCLT, ADMIN OXYG. KEEP WARM. GET IMMED MED ATTN.INGEST:
IF SWALLOWED, DO NOT INDUCE VOMIT. IF CONSCIOUS, GIVE SEVERAL
GLASSES OFICE WATER OR VERY COLD WATER TO DILUTE. CALL A MD OR
POIS CTL CTR IMMED. NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS
PERSON. IF UNCONSCIOUS, KEEP AIRWAY OPEN AND LAY ON SIDE WITH HEAD
LOWER THANBODY. GET IMMED MED ATTN. SKIN: REMOVE AND ISOLATE
CONTAM CLOTHING. WASH SKIN WITH SOAP AND FLUSH THOROUGHLY WITH
PLENTY OF WATER. OBTAIN MED ATTN IF IRRIT DEVELOPS, OR OTHER SYMPS
OCCUR. EYE: CHECK F OR CONTACT (OTHER PREC).
* Fire Fighting Measures *
Flash Point:NO DATA AVAIL.
Autoignition Temp:Autoignition Temp Text:N/AVAI
Lower Limits:NO DATA.
Upper Limits:NO DATA.
Extinguishing Media:THIS PRODUCT IS NOT FLAMMABLE. FOR FIRES INVOLVING
PACKAGING MATERIALS, USE AN AGENT APPROPRIATE FOR COMBUSTIBLES AND
SURROUNDING CLASS(ES) OF FIRE. AUTOIGNITION TEMP: NO DATA AVAIL.
Fire Fighting Procedures:KEEP UNNECESSARY PEOPLE AWAY. ISOLATE HAZARD
AREA AND DENY ENTRY. REMOVE CONTAINERS EXPOSED TO FIRE IF POSSIBLE,
OTHERWISE COOL THEM FROM THE SIDE WITH WATER SPRAY. EMERGENCY
EQUIPMENT INCLUDING NIOSH APPROVED SELF-CONTAINED BREATHING
APPARATUS (SCBA) & FULL FIRE FIGHTING TURNOUT GEAR SHOULD BE WORN
BY FIRE FIGHTERS.
Unusual Fire/Explosion Hazard:HYDROCHLORIC ACID SOLUTIONS ARE NOT
COMBUSTIBLE. HOWEVER, CONTACT WITH COMMON METALS, PRODUCES HYDROGEN
WHICH MAY FORM EXPLOSIVE MIXTURES WITH AIR.
* Accidental Release Measures *
Spill Release Procedures:ISOLATE SPILL. WEAR SPLASH-PROOF SFTY GOGG &
MATL (E.G., PAPER TOWELS, SPILL CONTROL PILLOWS, ABSORB
PARTICULATE). FOR LARGE SPILLS, CO NTAIN BY DIKING W/DRY SAND,
SORBENT BOOMS OR OTHER ABSORB MATL. PVNT RUNOFF INTO SEWERS, STORM
DARAINS, SURFACE WATERS, AND SOIL. NEUT BY APPLYING BASIC
SUBSTANCES SUCH AS SODA ASH (WASTE DISPOSAL).
Neutralizing Agent:BASIC SUBSTANCES SUCH AS SODA ASH AND SLAKED LIME OR
USING A COMMERCIALLY AVAILABLE ACID SPILL KIT.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER CLOSED WHEN NOT IN USE.
STORE AT ROOM TEMPERATURE IN A DRY, WELL-VENTILATED AREA, AWAY FROM
INCOMPATIBLE MATL.
Other Precautions:FIRST AID (CONT'D): LENSES & REMOVE IF PRESENT. HOLD
WHILE SEEKING IMMED ME D ATTN. DO NOT PUT ANY MEDICATIONS IN EYES
UNLESS INSTRUCTED BY PHYSICIAN.
* Physical/Chemical Properties *
Melt/Freeze Pt:M.P/F.P Text:NO DATA AVAILABLE.
Decomp Temp:Decomp Text:NO DATA AVAILABLE.
Vapor Pres:NO DATA AVAILABLE.
Vapor Density:NO DATA.
pH:<1.0
Viscosity:NO DATA AVAILABLE.
Solubility in Water:SEE FEDERAL REGULATIONS
Appearance and Odor:CLEAR LIQUID. ODORLESS.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
BASES, AMINES, ALKALI METALS, COPPER, COPPER ALLOYS, & ALUMINUM. INCR
IN TEMP/ PRESS OCCUR WHEN HYDROCHLORIC ACID WAS MIXED W/ FOLLOWING
CHEMS IN CLOSED CONTR:ACETIC ANHYDRIDE, 2-AMINOETHANOL, AMMONIUM
HYDROXIDE, CHLOROSULF
Stability Condition to Avoid:STABLE UNDER NORMAL COND OF USE & WHEN
STORED AT ROOM TEMP. AVOID HEAT, HIGH TEMPS, PRESSURE, MECH SHOCK,
CONTACT W/HEAT & FLAMM MATL. AVOID HEATING OR RUBBING W/OXIDIZABLE
CMPDS.
Hazardous Decomposition Products:HYDROGEN CHLORIDE GAS. MATLS TO AVOID
(CONT'D): ETHYLENE DIAMINE, ETHYLENEMINE, OLEUM, PROPIOLACTONE
(BETA-), SODIUM HYDROXIDE, SULFURIC ACID, VINYL ACETATE. MAY
CORRODE STEEL & ATTACKS (COND TO AVOID)
Conditions to Avoid Polymerization:HAZ DECOMP (CONT'D): NEARLY ALL
FORMS OF METAL. INADVERTANT MIXING OF HCL W/FORMALDEHYDE COULD FORM
BIS(CHLOROMETHYL)ETHER.
* Toxicological Information*
COMPOSITION/BIOCHEMICAL EFFECT. RPTD ORAL ADMIN OF DILUTE COMPOUND
(SARA)
* Ecological Information *
Ecological:NO DATA AVAILABLE FOR THE PRODUCT. THE FOLLOWING INFO HAS
DATA AVAILABLE FOR THE PRODUCT. THE FOLLOWING INFO HAS BEEN
REPORTED FOR THE INGREDIENT, HYDROCHLORIC ACID: WHEN RELEASED TO
SOIL, EXTENSIVE E VAPORATION WILL OCCUR, BUT HCI WILL TRANSPORT
THROUGH SOIL AND SOME ACID MAY REACH GROUNDWATER. HYDROGEN CHLORIDE
WILL ALMOST COMPLETELY DISSOCIATE IN WATER.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE & LOCAL REGULATIONS. SPILL/RELEASE (CONT'D):
AND SLAKED LIME OR USING A COMMERCIALLY AVAIL ACID SPILL KIT.
DECONTAM AREA. PLACE CONT AMD SORBENT OR OTHER CONTAMD MATL INTO
APPRVD WASTE CONTR FOR DISP. COMPLY WITH ALL APPLIC REGS ON S PILL
REPORTING. PRACTICE CONTAMINATION AVOIDANCE.
* MSDS Transport Information *
Transport Information:U. S. DOT: HYDROCHLORIC ACID MIXTURES ARE
REGULATED BY DOT AS FOLLOWS: PROPER SHIPPING NAME: HYDROCHLORIC
ACID, SOLUTION. LABEL REQUIRED: CORROSIVE. HAZARD CLASS: 8.
MODES OF TRANSPORTATION: AIR, RAIL, ROAD, AND WATER. THE FOLLOWING
INTERNATIONAL REGULATIONS APPLY TO HYDROCHLORIC ACID SOLUTIONS
(INTERNATIONAL AIR AND WATER SHIPMENTS): IMO CLASS: 8, CORROSIVE.
II.
* Regulatory Information *
SARA Title III Information:HYDROCHLORIC ACID: SARA TITLE III SECIONS
TO DOGS INDUCED ACUTE/CHRONIC GASTRITIS & DUODENITIS & LED TO
ULCERS ON PYFORUS. MUTAGENIC E FFECTS: HCL: DNA REPAIR (E.COLI);
SEX CHROMOSOME LOSS & NONDISJUNCTION (D. MELANOGASTER-INHALATION,
ORAL); CYTOGENIC ANALYSIS (GRASSHOPPER-PARENTERAL; HAMSTER-LUNG,
MG/M3 FOR 1 HOUR 1 DAY PRIOR TO MATING CAUSED FETOTOXICITY &
DEVELOPMENTAL ABNORMALITIES (HOMEOSTASIS) IN RATS.
Federal Regulatory Information:HYDROCHLORIC ACID: EPA TSCA CHEMICAL
INVENTORY; TSCA SECTION 8(E); EPA EXTREMELY HAZARDOUS SUBSTANCE
PROPERTIES: SOLUBILITY: WATER: VERY SOLUBLE (SOLUBLE IN LESS THAN
ONE PART WATER). OTHER SOLVENTS: SOLUBLE IN ALCOHOL, BENZENE,
ETHER. USE/SIZE: COMPONENT OF STONE ANALYSIS KIT USED FOR
QUANLITATIVE ANALYSIS OF THE CHEMICAL CONSTITUENTS OF URINARY
CALCULI/2 OZ.
State Regulatory Information:HYDROCHLORIC ACID: MASSACHUSETTS SUBSTANCE
LIST (EXTRAORDINARILY HAZARDOUS SUBSTANCE); NEW JERSEY RIGHT TO
KNOW HAZARDOUS SUBSTANCE LIST (ENVIRONMENTAL HAZARD); PENNSYLVANIA
HAZARDOUS SUBSTANCE LIST ( ENVIRONMENTAL HAZARD). EMERGENCY
OVERVIEW: HYDROCHLORIC ACID REAGENT IS CLEAR, ODORLESS LIQUID & IS
CORROSIVE. SOLUTIONS CONTAINING HYDROCHLORIC ACID ARE CORROSIVE TO
RESPIRATORY TRACT/SKIN/EYES. PROD UCT WILL DECOMPOSE TO HYDROGEN
CHLORIDE GAS. PRODUCT NOT COMBUSTIBLE; HOWEVER, ON CONTACT WITH
COMMO N METALS IT CAN PRODUCE HYDROGEN WHICH MAY FORM EXPLOSIVE
MIXTURES WITH AIR.
* Other Information *
| 1 | eyes_protection_mandatory |
Control Measures
*
Proprietary Ind: Y
*
Contractor Summary
*
*
Ingredients
*
-----------------------------
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE: EYE: MILD IRRITANT. INHALATION: LOW RISK OF
INHALATION, POTENTIAL EFFECTS INCLUDE DIZZINESS, NAUSEA, VISUAL IMPAIRMENT,
NARCOSIS, AND MUSCULAR IMPAIRMENT. SKIN: PROLONGED OR REPEATED CONTACT MA Y
CAUSE DERMATITIS, SCALING, AND POSSIBLE SYSTEMIC EFFECTS. INGESTION: TOXICITY
IS RELARIVELY LOW. (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: HEALTH HAZARDS: THERE IS A RISK OF
ASPIRATION OF PRODUCT INTO THE LUNGS. ON INGESTION OF LARGE QUANTITIES,
SLIGHT GI DISCOMFORT, DIARRHEA, AND HEADACHE MAY OCCUR. SMALL DOSES MAY
PRODUCE IRRITATION AN D DIARRHEA.
Medical Cond Aggravated By Exposure: NONE KNOWN.
OCCASIONALLY LIFTING EYELIDS. GET MED ATTN IMMED. SKIN: PROMPTLY WASH W/SOAP
INDUCE VOMIT. GET MED ATTN IMMED. INHAL: REMOVE TO FRESH AIR & CALL EMER
CARE. IF BRTHG HAS STOPPED, (SUP DAT)
*
Handling and Disposal
*
Spill Release Procedures: SML SPILL: REMOVE SOURCES OF HEAT/IGNIT. PROVIDE ADEQ
VENT. CONTAIN LEAK USING ABSORB, INERT, NON-COMBUST MATL. LGE SPILL: CONTAIN
SPILL. TRANSFER TO SECURE CONTRS. IN EVENT OF UNCONTROLLED MATL RELEA SE,
USER SHOULD DETERMINE IF RELEASE IS(SUP DAT)
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE OF PRODUCT IN ACCORDANCE WITH FEDERAL, STATE,
AND LOCAL REGULATIONS. BEFORE ATTEMPTING CLEAN UP, REFER TO OTHER SECTIONS OF
MSDS FOR HAZARD CAUTION INFORMATION.
Handling And Storage Precautions: PRODUCT IS FLAMMABLE. KEEP AWAY FROM SOURCES
OF IGNITION, COMBUSTIBLES, OXIDIZING MATERIALS, AND ACIDS.
Other Precautions: STORE IN AN AREA EQUIPPED WITH AUTOMATIC SPRINKLERS OR FIRE
EXTINGUISHING SYSTEM. EMPTY CONTAINERS CONTAIN PRODUCT RESIDUE, ASSUME
EMPTIED CONTAINERS TO HAVE SAME HAZARDS AS FULL CONTAINERS. KEEP AWAY FROM
CHILDREN!
*
Fire and Explosion Hazard Information
*
Flash Point Method: TOC
Lower Limits: 6%
Extinguishing Media: USE HALON REPLACEMENT/CARBON DIOXIDE EXTING/ALCOHOL FOAM
FOR SML FIRES. LGE FIRE SHOULD BE EXTINGUISHED W/ALCOHOL FOAM.
Fire Fighting Procedures: WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N). USE WATER SPRAY TO COOL CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard: FIRE HAZARD INCREASES AS TEMPERATURE RISES ABOVE
HAZAR WHEN EXPOSED TO HEAT OR FLAME.
*
*
Respiratory Protection: DO NOT USE AIR PURIFYING RESPIRATOR. USE APPROPRIATE
NIOSH APPROVED SUPPLIED/SELF CONTAINED RESPIRATOR. RESPIRATORS MUST BE
SELECTED BASED ON AIRBORNE LEVELS FOUND IN WORKPLACE & MUST NOT EXCEED
WORKI NG LIMITS OF RESPIRATOR.
Ventilation: LOCAL: TO MAINTAIN EXPOSURE LEVELS BELOW RECOMMENDED EXPOSURE
LIMITS. MECHANICAL: IN CONFINED SPACES.
Other Protective Equipment: ANSI APPRVD EMER EYEWASH & DELUGE SHOWER (FP N).
WEAR BODY-COVERING WORK CLOTHES TO PREVENT PROLONGED EXPOSURE.
Work Hygienic Practices: ALWAYS FOLLOW GOOD HOUSEKEEPING AND PERSONAL HYGIENE
PRACTICES. DO NOT WEAR CONTACT LENSES.
Supplemental Safety and Health: MATLS TO AVOID: ANHYDRIDE, LEAD PERCHLORATE,
& PERCHLORIC ACIDS. FIRST AID PROC: GIVE ARTF RESP. IF BRTHG IS DFCLT,
GIVE HUMIDIFIED OXYGEN. SPILL PROC: REPORTABLE UNDER APPLIC LAWS & REGS.
*
Physical/Chemical Properties
*
Vapor Density: 1.1
Solubility in Water: SOLUBLE
Appearance and Odor: AMBER LIQUID, SOLVENT ODOR
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: SOURCES OF IGNITION, COMBUSTIBLES, OXIDIZING
MATERIALS, AND ACIDS.
Materials To Avoid: STRONG OXIDIZING AGENTS, ALUMINUM, ZINC/METALS THAT
DISPLACE HYDROGEN, RUBBER & RUBBER BASED COATINGS, CHROMIC (SUP DAT)
Hazardous Decomposition Products: EXCESSIVE HEATING AND/OR INCOMPLETE
COMBUSTION WILL PRODUCE CARBON MONOXIDE AND TOXIC VAPORS SUCH AS
FORMALDEHYDE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
HAZCOM Label
*
Company Name: MERCURY MARINE
Label Required IND: Y
Status Code: C
Origination
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: Severe
Reactivity Hazard: None
Hazard And Precautions: FLAMMABLE. ACUTE: EYES: MILD IRRITANT. INHALATION: LOW
RISK, POTENTIAL EFFECTS INCLUDE DIZZINESS, NAUSEA, VISUAL IMPAIRMENT,
NARCOSIS AND MUSCULAR IMPAIRMENT. SKIN: PROLONGED OR REPEATED CONTACT MAY C
AUSE DERMATITIS, SCALING AND POSSIBLE SYSTEMIC EFFECTS. INGESTION: TOXICITY
IS RELATIVELY LOW. THERE IS A RISK OF ASPIRATION OF PRODUCT INTO LUNGS. LARGE
QUANTITIES CAUSE SLIGHT GASTROINTESTINAL DISCO MFORT, DIARRHEA, AND HEADACHE
MAY OCCUR. SMALL DOSES MAY PRODUCE IRRITATION ANDDIARRHEA. CHRONIC: NONE
SPECIFIED BY MANUFACTURER.
*
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Ventilation:LOCAL EXHAUST. USE GOOD BLOWER SYSTEM.
Supplemental Safety and Health
* Product Identification *
Product ID:GREEN ROUGE COMPOUND
* Composition/Information on Ingredients *
Ingred Name:STEARIC ACID
Ingred Name:ALPHA-ALUMINA (ALUMINUM OXIDE) (EPA LISTS ONLY FIBROUS
FORMS) (SARA III)
Ingred Name:PARAFFIN WAX
OSHA PEL:2 MG/M3 (FUME)
Ingred Name:CHROMIUM (III) OXIDE (2:3)
OSHA PEL:1 MG/CUM
ACGIH TLV:0.5 MG/CUM
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:DUST HAZARD ONLY.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:DUST HAZARD ONLY.
* Fire Fighting Measures *
Flash Point Method:COC
Extinguishing Media:REGULAR EXTINGUISHER
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
Spill Release Procedures:NO HAZARD. MATERIAL IS NON-TOXIC.
*Handling and Storage *
Handling and Storage Precautions:USE GOOD BLOWER SYSTEM.
Other Precautions:NONE
* Physical/Chemical Properties *
Spec Gravity:<1
Solubility in Water:INSOLUBLE
Appearance and Odor:GREEN-FATTY ODOR
Percent Volatiles by Volume:0%
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
* Disposal Considerations *
Waste Disposal Methods:CAN REMELT, REFORM OR USE NORMAL DISPOSAL
METHODS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF PERSONAL EXPOS CANNOT BE CONTROLLED BELOW
APPLIC LIMS BY VENT, WEAR PROPERLY FITTED NIOSH/MSHA APPRVD ORGANIC
VAP/PARTICULATE RESP FOR PROT AGAINST INGS. WHEN SANDING/ABRADING
Ventilation:LOCAL EXHAUST PREFERABLE. GENERAL EXHAUST ACCEPTABLE IF
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:WASH HANDS AFTER USING.
Supplemental Safety and Health
FIRE FIGHT PROC:TO PVNT PRESS BUILD-UP & POSS AUTOIGNIT/EXPLO WHEN
EXPOS TO EXTREME HEAT. EFTS OF OVEREXP:SYS DMG. INTENTIONAL MISUSE
BY DELIB CONC & INHAL CONTENTS CAN BE HARMFUL/FATAL. NOTE:TOLUENE
APPEARS ON NAVY LIST OF OCCUP CHEM REPRO HAZS. SEEK CONSULTATION
FROM APPROP HLTH PROFESSIONALS CONCERNING (ING 8)
* Product Identification *
CAGE:SPRYN
* Composition/Information on Ingredients *
ACGIH TLV:ASPHYXIANT
OSHA PEL:N/K
ACGIH TLV:N/K
Fraction by Wt: 5%
Ingred Name:PROPIONIC ACID, 3-ETHOXY-, ETHYL ESTER;
(ETHYL-3-ETHOXYPROPIONATE). VP:1.1.
Fraction by Wt: 3%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPP DATA:LATEST HAZARD LIST INFORMATION & SAFE HANDLING &
EXPOSURE INFORMATION .
Ingred Name:OTHER PREC:GROUNDING PROCS. CONTENTS UNDER PRESS. DO NOT
Ingred Name:ING 9:SUNLIGHT, RADIATORS, STOVES, HOT WATER & OTHER HEAT
Ingred Name:RESP PROT:PROTECTION AGAINST NON-VOLATILE MATERIALS IN
INGREDIENTS.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EXPOS MAY BE BY INHAL &/OR SKIN/EYE
CONT, DEPENDING ON CNDTNS OF USE. TO MIN EXPOS, FOLLOW RECS FOR
PROPER USE, VENT & PERSONAL PROT EQUIP. ACUTE:IRRIT OF EYES, SKIN &
RESP SYS. MAY CAUSE NERV SYS DEP RESS. EXTREME OVEREXP MAY RSLT IN
UNCON& POSSIBLY DEATH. HDCH, DIZZ, NAUS & LOSS OF COORD ARE (EFTS
OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:INDICATIONS OF EXCESSIVE EXPOS TO
VAPS/SPRAY MISTS. REDNESS & ITCH/BURNING SENSATION MAY INDICATE
EYE/EXCESSIVE SKIN EXPOS. CHRONIC:PRLNG OVEREXP TO SOLV INGS MAY
CAUSE ADVERSE EFTS TO LIVER, URINARY, BLOOD-FORMING, CVS & REPRO
SYS. REPORTS HAVE ASSOC RPTD & PRLNG OVEREXP TO SOLVS W/PERM BRAIN
& NERV (SUPDAT)
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.
* First Aid Measures *
First Aid:INHAL:REMOVE FROM EXPOSURE. RESTORE BREATHING. KEEP WARM &
QUIET. SKIN:WASH AFFECTED AREA THOROUGHLY W/SOAP & WATER. REMOVE
CONTAMINATED CLOTHING & LAUNDER BEFORE RE-USE. EYES:FLUSH W/LARGE
INGEST:NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. DO
NOT INDUCE VOMITING. GIVE SEVERAL GLASSES OF WATER. SEEK MEDICAL
ATTENTION.
* Fire Fighting Measures *
Flash Point Method:PMCC
Lower Limits:1%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:USE NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP.
WATER SPRAY MAY BE INEFT. IF WATER IS USED, FOG NOZZ ARE PREF.
WATER MAY BE USED TO COOL CLSD CNTNRS(SUPDAT)
Unusual Fire/Explosion Hazard:EXTREMELY FLAMMABLE. CLOSED CONTAINERS
MAY EXPLODE (DUE TO THE BUILD-UP OF PRESSURE) WHEN EXPOSED TO
EXTREME HEAT.
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE &
REMOVE W/INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:DOL STOR CATEGORY-1A. CONTENTS ARE
EXTREMELY FLAMM. KEEP AWAY FROM HEAT, SPKS & OPEN FLAME. VAPS WILL
ACCUM READILY & IGNITE EXPLOSIVELY.
Other Precautions:DURING USE & UNTIL ALL VAPS ARE GONE:KEEP AREA
VENTILATED; DO NOT SMOKE; EXTING ALL FLAMES, PILOT LIGHTS &
HEATERS; TURN OFF STOVES, ELEC TOOLS & APPLIANCES & ANY OTHER
SOURCES OF IGNIT. CONSULT NFPA CODE. USE APPRVD BONDING & (ING 9)
* Physical/Chemical Properties *
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Evaporation Rate & Reference:FASTER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:OXIDES OF METALS LISTED IN
INGREDIENTS.
* Disposal Considerations *
Waste Disposal Methods:WASTE FROM THIS PROD MAY BE HAZ AS DEFINED UNDER
DETERMINE APPLIC EPA HAZ WASTE NUMBERS. DO NOT INCIN. DEPRESSURIZE
CNTNR. DISP OF I/A/W FED, STATE & LOC REGS REGARDING POLLUTION.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF EXPOSURE MAY OR DOES EXCEED OCCUPATIONAL
EXPOSURE LIMITS, USE A NIOSH-APPROVED RESPIRATOR TO PREVENT
ATMOSPHERE-SUPPLYING RESPIRATOR OR AN AIR-PURIFIYING RESPIRATOR
FOR ORGANICS.
Ventilation:USE EXPLOSION-PROOF VENTILATION AS REQUIRED TO CONTROL
VAPOR CONCENTRAATIONS.
Other Protective Equipment:CHEMICAL RESISTANT CLOTHING TO MINIMIZE
CONTACT.
Work Hygienic Practices:WASH WITH SOAP AND WATER AFTER HANDLING PRODUCT
AND BEFORE EATING DRINKING OR SMOKING.
Supplemental Safety and Health
NOTE TO PHYSICIAN: IF MORE THAN 2.0 ML PER KG HAS BEEN INGESTED AND
VOMITING HAS NOT OCCURRED, EMESIS SHOULD BE INDUCED WITH
SUPERVISION. KEEP VICTIM'S HEAD BELOW HIPS TO PREVENT ASPIRATION.
IF SYMPTO MS SUCH AS LOSS OF GAG REFLEX, CONVULSIONS OR
UNCONSCIOUSNESS OCCUR BEFORE EMESIS, GASTRIC LAVAGE SHOULD BE
CONSIDERED.
* Product Identification *
Product ID:SHELL TURBINE FUEL, JP-5
Preparer's Name:G.A. VAN GELDER
* Composition/Information on Ingredients *
Ingred Name:JP-5- JET FUEL (NAVY)
Ingred Name:MINOR ADDITIVES (SEE SECTIONS 3.3.1 & 3.3.2 OF SPEC)
Fraction by Wt: <0.5%
Ingred Name:KEROSENE
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MINIMAL EYE IRRITATION WITH SHORT TERM
PROLONGED AND REPEATED CONTACT MAY BE MORE IRRITATING.
MODERATE SKIN IRRITATION. PROLONGED AND REPEATED CONTACT CAN CAUSE
DEFATTING AND DRYING OF SKIN W HICH MAY RESULT IN DERMATITIS.
INHALATION MAY CAUSE RESPIRATORY TRACT IRRITATION. INGESTION IS AN
ASPIRATION HAZARD.
Explanation of Carcinogenicity:KEROSENE HAS BEEN SHOWN TO PRODUCE SKIN
CANCER IN EXPERIMENTAL ANIMALS UPON REPEATED DERMAL APPLICATION.
Effects of Overexposure:EYE IRRITATION, SKIN
IRRITATION/DEFATTING/DRYING/DERMATITIS, RESPIRATORY TRACT
IRRITATION, GIDDINESS, HEADACHE, DIZZINESS, NAUSEA, ASPIRATION
PNEUMONITIS MAY BE EVIDENCED BY COUGHING, LABORED BREATHIN G AND
CYANOSIS.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN AND RESPIRATORY
DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS PRODUCT.
* First Aid Measures *
First Aid:EYES: FLUSH WITH WATER. IF IRRITATION OCCURS, GET MEDICAL
ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING. FLUSH SKIN WITH
WATER. IF IRRITATION OCCURS, GET MEDICAL ATTENTION. INHALATION:
REMOVE TO FRESH AIR AND PROVIDE OXYGEN IF BREATHING ISDIFFICULT.
GET MEDICAL ATTENTION. INGESTION: DO NOT INDUCE VOMITING. IF
VOMITING OCCURS SPONTANEOUSLY, KEEP HEAD BELOW HIPS TO PREVENT
ASPIRATION INTO LUNGS.
* Fire Fighting Measures *
Flash Point Method:PMCC
Lower Limits:0.7 %
Upper Limits:5.0 %
Extinguishing Media:USE WATER FOG, FOAM, DRY CHEMICAL OR CARBON
DIOXIDE. DO NOT USE A DIRECT STREAM OF WATER. PRODUCT WILL FLOAT ON
WATER.
Fire Fighting Procedures:DO NOT ENTER CONFINED FIRE SPACE WITHOUT FULL
BUNKER GEAR, INCLUDING A POSITIVE PRESSURE NIOSH APPROVED
SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:CONTAINERS EXPOSED TO INTENSE HEAT FROM
FIRES SHOULD BE COOLED WITH WATER TO PREVENT VAPOR PRESSURE BUILDUP
WHICH COULD RESULT IN CONTAINER RUPTURE.
* Accidental Release Measures *
Spill Release Procedures:ELIMINATE POTENTIAL SOURCES OF IGNITION. WEAR
APPROPRIATE RESPIRATOR AND OTHER PROTECTIVE CLOTHING. SHUT OFF
SOURCE OF LEAK ONLY IF SAFE TO DO SO. REMOVE WITH VACUUM TRUCKS OR
PUMP. SOAK UP RESIDUE WI TH ABSORBENT SUCH AS CLAY, SAND.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:KEEP LIQUID AWAY FROM HEAT, SPARKS AND
FLAME. SURFACES THAT ARE HOT MAY IGNITE LIQUID IN THE ABSENCE OF
SPARKS OR FLAME. EXTINGUISH PILOT LIGHTS.
Other Precautions:VAPORS MAY ACCUMULATE AND TRAVEL TO IGNITION SOURCES
DISTANT FROM THE HANDLING SITE; FLASH FIRE CAN RESULT. KEEP
CONTAINERS CLOSED WHEN NOT IN USE. CONTAINERS, EVEN WHEN EMPTY, CAN
CONTAIN EXPLOSIVE VAPORS. DO NOT CUT, WELD, DRILL OR GRIND
* Physical/Chemical Properties *
HCC:F4
Vapor Pres:NOT GIVEN
Vapor Density:> 1
Evaporation Rate & Reference:NOT GIVEN
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR WHITE LIQUID, KEROSENE ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS
Stability Condition to Avoid:AVOID HEAT, SPARKS, FLAME
Hazardous Decomposition Products:COMPLEX MIXTURE OF AIRBORNE SOLID,
LIQUID, PARTICULATES AND GASES WILL EVOLVE. CARBON MONOXIDE AND
UNIDENTIFIED ORGANICS
* Disposal Considerations *
Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT, RESIDUE, DISPOSAL CONTAINER OR
LINER IN ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL REGULATIONS.
| 0 | eyes_protection_not_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF ENGINEERING CONTROLS DO NOT MAINTAIN AIRBORNE
CONCENTRATIONS TO A LEVEL WHICH IS ADEQUATE TO PROTECT WORKER
HEALTH, AN APPROVED RESPIRATOR MUST BE WORN. RESPIRATOR SELECTION,
USE AND MAINTENANCE SH OULD BE IN ACCORDANCE WITH REQUIREMENTS OF
Ventilation:ADEQUATE EXPLOSION-PROOF VENTILATION TO CONTROL AIRBORNE
CONCENTRATIONS BELOW THE EXPOSURE GUIDELINES/LIMITS.
GLASSES.
Other Protective Equipment:USE PROTECTIVE CLOTHING WHICH IS CHEMICAL
RESISTANT TO THIS MATERIAL. SELECTION OF PROTECTIVE CLOTHING
BOOTS, SUITS AND OTHER ITEMS.
Work Hygienic Practices:AVOID CONTACT WITH EYES, SKIN & CLOTHING. AVOID
PROLONGED OR REPEATED CONTACT WITH EYES, SKIN & CLOTHING. WASH
THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
RESPIRATOR: TYPES: AIR-PURIFYING RESPIRATOR FOR ORGANIC VAPORS,
SUPPLIED-AIR RESPIRATOR, SELFCONTAINED BREATHING APPARATUS: FOR USE
IN ENVIRONMEN WITH UNKNOWN CONCENTRATIONS OR EMERGENCY SITUATIONS.
* Product Identification *
Preparer's Name:SUSAN EASTRIDGE
* Composition/Information on Ingredients *
Ingred Name:SOLVENT NAPHTHA (PETROLEUM), LIGHT ALIPHATIC
* Hazards Identification *
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS: HEART, AUDITORY SYSTEM.
INHALATION-BREATHING OF HIGH VAPOR CONCENTRATIONS MAY CAUSE CENTRAL
NERVOUS SYSTEM DEPRESSION. CONTINUED INHALATION MAY RESULT IN
UNCONSCIOUSNESS/DEATH. CHRONIC ABUSE HAS BEEN ASSOCIATED WITH
IRREGULAR HEART RHYTHMS & POTENTIAL CARDIAC ARREST. EYE-MAY CAUSE
TEMPORARY DISCOMFORT OR IRRITATION. SKIN-MAY BE SLIGHTLY
IRRITATING. PROLONGED OR REPEATED SKIN CONTAC T CAN CAUSE DEFATTING
& DRYING OF THE SKIN. INGESTION-LIQUID CAN DIRECTLY ENTER THE LUNGS
(ASPIRATION) WHEN SWALLOWED OR VOMITED. SERIOUS LUNG DAMAGE &
POSSIBLY FATAL CHEMICAL PNEUMONIA (CHEMICAL PNEU MONITIS) CAN
DEVELOP IF THIS OCCURS.
Explanation of Carcinogenicity:MUTAGENICITY: SOME EFFECTS TO
CHROMOSOMES BUT NO MUTAGENIC EFFECTS WERE OBSERVED IN GENOTOXICITY
STUDIES CONDUCTED FOR SIMILAR HYDROCARBON SOLVENT MIXTURES. THE
BIOLOGICAL SIGNIFICANCE OF THE CHROMOSO MAL FINDINGS IS UNKNOWN.
Effects of Overexposure:INHALATION: BREATHING OF HIGH VAPOR
CONCENTRATIONS MAY CAUSE CNS DEPRESSION RESULTING IN DIZZINESS,
LIGHT-HEADEDNESS, HEADACHE, NAUSEA AND LOSS OF COORDINATION.
CONTINUED INHALATION MAY RESULT IN UNC ONSCIOUSNESS/DEATH. VAPORS
EXPECTED TO BE SLIGHTLY IRRITATING. PROLONGED AND REPEATED
EXPOSURES TO HIGH CONCENTRATIONS MAY CAUSE HEARING LOSS. SKIN:
PROLONGED OR REPEATED SKIN CONTACT CAN CAUSE DEFATT ING & DRYING OF
THE SKIN WHICH MAY RESULT IN A BURNING SENSATION AND A DRIED,
CRACKED APPEARANCE. INGESTION: SERIOUS LUNG DAMAGE AND POSSIBLY
FATAL CHEMICAL PNEUMONITIS (CHEMICAL PNEUMONITIS) CAN DEVE LOP IF
THIS OCCURS.
* First Aid Measures *
First Aid:INHALATION-MOVE VICTIM TO FRESH AIR. IF DIFFICULTY
BREATHING/TIGHTNESS IN CHEST, DIZZY, VOMITING OR UNRESPONSIVE, GIVE
NEAREST MEDIC AL FACILITY. SKIN-WIPE OFF EXCESS MATEIRAL. FLUSH
SKIN WITH WATER. FOLLOW BY WASHING WITH SOAP IF AVAILABLE. IF
REDNESS, PAIN, BLISTERS OCCUR, TAKE TO HOSPITAL FOR TREATMENT.
MINS. CONSULT PHYSICIAN IF NEEDED. INGESTION-DO NOT INDUCE
VOMITING. RINSE MOUTH. GET MEDICAL ADVISE. "SEE OTHER INFO"
* Fire Fighting Measures *
Flash Point Method:SCC
Lower Limits:1
Upper Limits:8
Extinguishing Media:USE WATER FOG, FOAM, DRY CHEMICAL OR CO2 TO
EXTINGUISH FLAMES. DO NOT USE A DIRECT STREAM OF WATER. MATERIAL
WILL FLOAT & REIGNITE ON SURFACE OF WATER.
Fire Fighting Procedures:EXTREMELY FLAMMABLE. CLEAR FIRE AREA OF ALL
NON-EMERGENCY PERSONNEL. DO NOT ENTER CONFINED FIRE SPACE WITHOUT
RUBBER BOOTS), INCLUDING APOSITIVE PRESSURE, NIOSH APPROVED,
SELF- CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:CONTAINERS EXPOSED TO INTENSE HEAT FROM
FIRES SHOULD BE COOLED WITH WATER TO PREVENT WEAKENING OF CONTAINER
STRUCTURE WHICH COULD RESULT IN CONTAINER RUPTURE. VAPORS ARE
FLAMMABLE AND HEAVIER THAN AIR .AND MAY TRAVEL TO REMOTE IGNITION
SOURCE CAUSING A FLASHBACK FIRE DANGER.
* Accidental Release Measures *
Spill Release Procedures:SHUT OFF SOURCE OF LEAK IF SAFE TO DO SO. DIKE
& CONTAIN SPILL. USE WATER SPRAY(FOG) TO REDUCE VAPORS OR DIVERT
VAPOR CLOUD DRIFT. IF VAPOR CLOUD FORMS, USE WATER FOG TO SUPRESS
OR BLANKET SPILL AREA WITH FOAM. REMOVE WITH VACUUM TRUCK OR PUMP
TO STORAGE/SALVAGE VESSELS. SOAK UP RESIDUE WITH AN ABSORBENT SUCH
AS CLAY, SAND OR SUITABLE MATERIAL & DISPOSE OF PROPERLY. FLUSH
AREA WITH WATER.
*Handling and Storage *
Handling and Storage Precautions:STORAGE-KEEP CONTAINERS CLOSED WHEN
NOT IN USE. GROUND FIXED EQUIPMENT. HANDLING-STATIC ELECTRICITY
MAY ACCUMULATE & CREATE A FIRE HAZARD. SURFACES THAT ARE
SUFFICIENTLY HOT MAY IGNITE LIQUID MATERIA L. VAPORS ARE FLAMMABLE
& HEAVIER THAN AIR.
Other Precautions:HANDLING -VAPOR MAY TRAVEL ACROSS THE GROUND & REACH
REMOTE IGNITION SOURCES CAUSING A FLASHBACK FIRE DANGER. KEEP AWAY
FROM HEAT, SPARKS & FLAME. EXTINGUISH PILOT LIGHTS, CIGARETTES &
TURN OFF OTHER IGNITION SOURCES PRIOR TO USE & UNTIL ALL VAPORS
HAVE DISSIPATED. USE EXPLOSION-PROOF VENTILATION.
* HMIS RATING (HEALTH, FIRE REACTIVITY): 1,3,0.
* Physical/Chemical Properties *
HCC:F2
Vapor Density:3.3
VOC Grams/Liter:6.1
Evaporation Rate & Reference:3.2 (NBUAC=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:LIGHT COLORED LIQUID; HYDROCARBON ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
CONTACT WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:PREVENT VAPOR ACCUMULATION. AVOID HEAT,
SPARKS, FLAME AND OTHER IGNITION SOURCES.
Hazardous Decomposition Products:CARBON MONOXIDE AND UNIDENTIFIED
ORGANIC COMPOUNDS MAY BE FORMED DURING COMBUSTION.
* Toxicological Information*
Toxicological Information:ACUTE TOXICITY: HYDROCARBON SOLVENT:
[RABBIT] MATERIAL TESTED-SOLVENT NAPTHA, LIGHT ALIPHATIC. SKIN
IRRITATION: MINIMALLY IRRITATING MATERIAL TESTED-HYDROCARBON
SOLVENT. OTHER TESTING: KIDNEY EFFECTS IN MALE RATS WERE OBSERVED
IN LAB ANIMALS EXPOSED TO A SIMILAR MATERIAL. EFFECTS WERE
CONSISTENT WITH MALE HYALINE DROPLETS NEPHROPATHY WHICH IS
QUESTIONABLE SIGNIFICANCE TO HUMAN HEALTH.
* Ecological Information *
Ecological:THIS SECTION WILL BE UPDATED AS ECOLOGICAL REVIEWS ARE
COMPLETED.
* Disposal Considerations *
BECOMES A WASTE MATERIAL, IT WOULD BE AN IGNITABLE HAZARDOUS WASTE,
REGULATIONS REGARDING PROP ER DISPOSAL.
* MSDS Transport Information *
Transport Information:US DEPARTMENT OF TRANSPORTATION CLASSIFICATION:
PROPER SHIPPING NAME: PETROLEUM DISTILLATES, N.O.S. TECHNICAL
CLASS/DIVISION: 3(FLAMMABL E LIQUID). PACKING GROUP: II. OIL: THIS
* Regulatory Information *
HAZARD. DELAYED(CHRONIC) HEALTH HAZARD. THIS MATERIAL IS COVERED BY
CERCLA PETROLEUM EXCLUSION.
Federal Regulatory Information:RESOURCE CONSERVATION & RECOVERY ACT
SUBSTANCE COINTROL ACT (TSCA) STATUS: THIS MATERIAL IS LISTED ON
THE EPA/TSCA INVENTORY OF CHEMICALSUBSTANCES. REPORTING-THIS
MATERIAL IS COVERED BY THE EPA'S CERCLA PETROLEUM EXCLUSION.
THEREFORE, RELEASES TO THE ENVIRONMENT MAY NOT BE REPORTABLE UNDER
CERCLA. NOTIFY AUTHORITIES IF ANY EXPOSURES T O THE GREATER PUBLIC
OR ENVIRONMENT OCCURS OR IS LIKELY TO OCCUR.
State Regulatory Information:CALIFORNIA SAFE DRINKING WATER AND TOXIC
KNOWN TO THE STATE OF CALIFORN IA TO CAUSE BIRTH DEFGECTS OR OTHER
REPRODUCTIVE HARM. NEW JERSEY RIGHJT-TO-KNOW CHEMICAL LIST: HEPTANE
* Other Information *
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR A PROPERLY FITTED VAPOR/PARTICULATE
RESPIRATOR APPROVED BY NIOSH/MSHA FOR USE W/PAINTS DURING
APPLICATIONS. IN CONFINED AREAS, USE A POSITIVE-PRESSURE, SUPPLIED
AIR RESPIRATOR.
Ventilation:SUFFICIENT VENTILATION IN VOLUME & PATTERN TO KEEP
CONTAMINANTS BELOW APPLICABLE OSHA REQUIREMENTS.
Other Protective Equipment:COVERALLS.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING & BEFORE
EATING/SMOKING.
Supplemental Safety and Health
* Product Identification *
Preparer's Name:T R LOUER
* Composition/Information on Ingredients *
Ingred Name:ETHYL 3-ETHOXYPROPIONATE, PROPANOIC ACID, 3-ETHOXY-, ETHYL
Ingred Name:METHYL PARAHYDROXYBENZOATE, METHYLPARABEN
Ingred Name:PROPYLENEGLYCOL MONOMETHYL ETHER ACETATE,
1-METHOXY-2-PROPANOL ACETATE
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: NOSE & THROAT IRRITATION.
REPEATED/PROLONGED OVEREXPOSURE TO SOLVENTS MAY CAUSE PERMANENT
BRAIN & NERVOUS SYSTEM DAMAGE. SKIN: IRRITATION, DERMATITIS. EYES:
IRRITATION, BURNING.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, EYE WATERING, HEADACHES, NAUSEA,
DIZZINESS, LOSS OF COORDINATION, DISCOMFORT, GI DISTRESS.
* First Aid Measures *
First Aid:INGESTION: CALL A PHYSICIAN IMMEDIATELY & HAVE THE NAMES OF
INGREDIENTS AVAILABLE. INHALATION: REMOVE TO FRESH AIR. SKIN: WASH
ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Lower Limits:0.2
Extinguishing Media:WATER SPRAY, FOAM, CO2, DRY CHEMICAL.
Fire Fighting Procedures:WEAR FULL PROTECTIVE EQUIPMENT W/SCBA. WATER
FROM FOG NOZZLES MAY BE USED TO COOL CLOSED CONTAINERS.
Unusual Fire/Explosion Hazard:WHEN HEATED ABOVE THE FLASH POINT, EMITS
FLAMMABLE VAPORS WHICH, WHEN MIXED W/AIR, CAN BURN/EXPLODE. FINE
Other Precautions:DON'T SAND, FLAME CUT, BRAZE/WELD DRY COATING W/O
NIOSH/MSHA APPROVED RESPIRATOR/APPROPRIATE VENTILATION. DON'T
BREATHE VAPORS/MISTS. DON'T PERMIT ANYONE W/O PROTECTION IN THE
PAINTING AREA.
* Physical/Chemical Properties *
Vapor Density:>1
VOC Grams/Liter:7.4
Evaporation Rate & Reference:LESS THAN ETHER
Solubility in Water:MISCIBLE
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:CO, CO2, SMOKE
* Disposal Considerations *
Waste Disposal Methods:DON'T ALLOW MATERIAL TO CONTAMINATE GROUND WATER
SYSTEMS. INCINERATE ABSORBED MATERIAL IAW/FEDERAL, STATE & LOCAL
| 1 | eyes_protection_mandatory |
Control Measures
*
Cage: CMPST
Proprietary Ind: Y
*
Contractor Summary
*
Cage: CMPST
*
Ingredients
*
-----------------------------
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: HARMFUL OR FATAL IF SWALLOWED! IRRITANT WHEN IN CONTACT
WITH EYES OR WITH OPEN, ABRADED SKIN. TRACE AMOUNTS OF ETHYLENE OXIDE, A
SUBSTANCE WHICH MAY BE A HUMAN CARCINOGEN & A REPRODUCTIVE TOXICANT, MA Y
BE CONTAINED IN THIS PRODUCT. THE LEVEL IN THIS PRODUCT DOES NOT CONSTITUTE A
SIGNIFICANT RISK.
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: INHAL: REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE
OXYGEN/ARTIFICIAL RESPIRATION) (FP N). EYES: FLUSH PROMPTLY W/COPIOUS AMOUNTS
WASH THORO W/SOAP & WATER. REMOVECONTAMINATED CLTHG & SEEK MEDICAL
ATTENTION IF NECESSARY. INGEST: RINSE MOUTH. DRINK A GLASS FULL OF
WATER/MILK. IF DISCOMFORT PERSISTS, SEEK MEDICAL ATTENTION.
*
Handling and Disposal
*
Spill Release Procedures: EXTINGUISH ALL SOURCES OF FLAME OR IGNITION. ABSORB
WITH INERT MATERIAL SUCH AS VERMICULITE OR SAND. SWEEP UP & COLLECT IN
CONTAINERS TO DISPOSE OF AS SOLID WASTE. WASH THE AREA WITH TRISODIUM PHOSPHA
TE & WATER.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE &
LOCAL REGULATIONS REGARDING WASTE.
AWAY FROM SOURCES OF HEAT & IGNITION. USE EXPLOSION PROOF EQUIPMENT.
Other Precautions: OPEN CONTAINERS SLOWLY TO RELIEVE ANY INTERNAL PRESSURE. USE
WITH ADEQUATE VENTILATION. KEEP OUT OF REACH OF CHILDREN.
*
Fire and Explosion Hazard Information
*
Flash Point Method: TCC
Extinguishing Media: DRY CHEMICAL, FOAM & CARBON DIOXIDE.
Fire Fighting Procedures: USE NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT (FP N). COOL SURROUNDING AREA WITH WATER.
Unusual Fire/Explosion Hazard: IF EXPOSED TO ELEVATED TEMPERATURE FOR EXTENDED
LENGTH OF TIME, AN EXPLOSIVE DECOMPOSITION MAY OCCUR.
*
*
Respiratory Protection: USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN (FP N).
Ventilation: ANY COMBINATION OF LOCAL & GENERAL VENTILATION TO DRAW FUMES
AWAY FROM WORKERS.
Other Protective Equipment: PROTECTIVE CLOTHING, SHOES, ANSI APPRVD EYE WASH
STATION & SAFETY SHOWERS SHOULD BE AVAILABLE.
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: NONE SPECIFIED BY MANUFACTURER.
*
Physical/Chemical Properties
*
HCC: P1
B.P. Text: DECOMPOSES
Vapor Density: <1
Spec Gravity: 1.2
Evaporation Rate & Reference: FASTER THAN DIETHYL ETHER
Appearance and Odor: PIGMENTED PASTE.
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: STORAGE IN OPEN CONTAINERS, PROLONGED STORAGE
Materials To Avoid: STRONG ACIDS, STRONG ALKALIS, STRONG OXIDIZERS, REDUCING
AGENTS, MINERAL ACIDS, METAL SALT CATALYSTS.
Hazardous Decomposition Products: NONE SPECIFIED BY MANUFACTURER.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
HAZCOM Label
*
Cage: CMPST
Company Name: COMPOSITITE INC
Label Required IND: Y
Status Code: C
Origination Code: G
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: Moderate
Reactivity Hazard: None
Hazard And Precautions: COMBUSTIBLE. ACUTE: HARMFUL OR FATAL IF SWALLOWED!
IRRITANT WHEN IN CONTACT WITH EYES OR WITH OPEN, ABRADED SKIN. CHRONIC: NONE
SPECIFIED BY MANUFACTURER.
*
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NO INFORMATION GIVEN BY MFR ON MSDS.
RATES SHOULD MATCH CONDITIONS OF USE.
Other Protective Equipment:NO INFORMATION GIVEN BY MFR ON MSDS.
Work Hygienic Practices:MFR: ?HMIS:USE GOOD INDUSTRIAL HYGIENE
PRACTICE. AVOID UNNECESSARY EXPOSURE. WASH THOROUGHLY BEFORE EATING
OR DRINKING
Supplemental Safety and Health
NONE
* Product Identification *
Product ID:2-STEP, DEVELOPER PART A
* Composition/Information on Ingredients *
Ingred Name:WATER
Other REC Limits: RECOMMENDED
Ingred Name:SODIUM METABISULFITE
Fraction by Wt: 1-5%
Other REC Limits: RECOMMENDED
OSHA PEL:5 MG/M3
Ingred
Name:4-(N-ETHYL-N-2-METHANESULFONYLAMINOETHYL)-2-METHYLPHENYLENEDIA
MINE
Other REC Limits: RECOMMENDED
Ingred Name:BENZYL ALCOHOL
Other REC Limits: RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION:LOW HAZARD FOR USUAL
HANDLING; VAPOR IRRITATING. INGESTION:IF SSWALLOWED, INDUCE
VOMITING. EYES:LIQUID CAUSES IRRITATION; VAPOR IRRITATING. SKIN
CONTACT:CAUSES IRRITATION, MAY CAUSE ALLERGI C SKIN REACTION.
Explanation of Carcinogenicity:MFR LISTED NO INFORMATION ABOUT THE
CARCINOGENICITY OF THIS MATERIAL. HMIS DOES NOT EXPECT IT TO BE
CARCINOGENIC.
Effects of Overexposure:INHALATION:LOW HAZARD FOR USUAL HANDLING; VAPOR
IRRITATING. INGESTION:IF SSWALLOWED, INDUCE VOMITING. EYES:LIQUID
CAUSES IRRITATION; VAPOR IRRITATING. SKIN CONTACT:CAUSES
IRRITATION, MAY CAUSE ALLERGI C SKIN REACTION.
Medical Cond Aggravated by Exposure:NO INFORMATION GIVEN BY MFR ON
MSDS.
* First Aid Measures *
IMMEDIATE MEDICAL ATTENTION. SKIN:FLUSH SKIN W/PLENTY OF WATER AND
WASH W/A NON-ALKALIND SKIN CLEANER. GET MEDICAL ATTENTION IF
ALLERGIC SKIN REACTION DEVELOPES.INGESTION:INDUCE VOMITING. GET
IMMEDIATE MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point:
Extinguishing Media:USE AGENT APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING TO PREVENT CONTACT WITH SKIN AND EYES.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY CAUSE
PRODUCTION OF HAZARDOUS DECOMPOSITION PRODUCTS.
* Accidental Release Measures *
Spill Release Procedures:FLUSH TO SEWER SITH LARGE AMOUNTS ON WATER.
Neutralizing Agent:NO INFORMATION GIVEN BY MFR ON MSDS.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED. STORE
AWAY FROM CHILDREN.
Other Precautions:
* Physical/Chemical Properties *
HCC:N1
NRC/State Lic Num:
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR LIGHT AMBER SOLUTION, SULFUR DIOXIDE ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, STRONG ALKALI
Stability Condition to Avoid:NO INFORMATION GIVEN BY MFR ON MSDS.
Hazardous Decomposition Products:CARBON DIOXIDE AND CARBON MONOXIDE ARE
LIKELY. OXIDES OF SULFUR AND NITROGEN MAY ALSO BE PRESENT.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
* Disposal Considerations *
Waste Disposal Methods:DISCHARGE, TREATMENT OR DISPOSAL MAY BE SUBJECT
TO FEDERAL, STATE, (PROVINCIAL IN CANADA) OR LOCAL LAWS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN
Ventilation:FUME HOOD.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER, LAB
COAT.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
IN/YR.
* Product Identification *
Kit Part:Y
* Composition/Information on Ingredients *
Ingred Name:POTASSIUM PYROSULFATE
Ingred Name:L-ASCORBIC ACID
Ingred Name:MOLYBDIC ACID, DISODIUM SALT; (SODIUM MOLYBDATE)
< Wt:5.
OSHA PEL:5 MG/M3 MO
ACGIH TLV:5 MG/M3 MO
Ingred Name:OTHER COMPONENTS, EACH
< Wt:1.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:THIS PRODUCT MAY BE CORROSIVE TO EYES,
WET SKIN AND RESPIRATORY TRACT. TOXIC DUE TO CORROSIVITY. TARGET
ORGANS: ALL BODY TISSUES.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:OVEREXPOSURE CAUSES EYE BURNS AND MAY BE
IRRITATING TO RESPIRATORY TRACT. MAY AFFECT ENZYME ACTIVITY, INDUCE
COPPER DEFICIENCY, MAY CAUSE ANEMIA, GOUT, LIVER DAMAGE. MAY CAUSE
LOSS OF COORDINATION AND APPETITE.
Medical Cond Aggravated by Exposure:CHRONIC RESPIRATORY CONDITIONS,
BLOOD DISEASES. GOUT MAY BE AGGRAVATED BY EXPOSURE TO MOLYBDENUM
COMPOUNDS.
* First Aid Measures *
CALL MD. SKIN: REMOVE CONTAMINATED CLOTHING. WASH SKIN WITH SOAP
AND PLENTY OF WATER. INGEST: DO NOT INDUCE VOMITING. GIVE 1-2
GLASSES OF WA TER. CALL MD IMMEDIATELY. NEVER GIVE ANYTHING BY
MOUTH TO AN UNCONSCIOUS PERSON. INHAL: REMOVE TO FRESH AIR. GIVE
ARTIFICIAL RESPIRATION IF NECESSARY. CALL MD.
* Fire Fighting Measures *
Extinguishing Media:WATER, CARBON DIOXIDE OR DRY CHEMICALS.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT
Unusual Fire/Explosion Hazard:MAY EMIT TOXIC FUMES OF SULFUR OXIDES.
* Accidental Release Measures *
Spill Release Procedures:COVER CONTAMD SURFACES W/SODA ASH OR SODIUM
BICARBONATE. MIX & ADD WATER IF NECESSARY. USE LITMUS PAPER TO MAKE
SURE PH OF SLURRY IS NEUTRAL OR ADD NEUTRALIZER UNTIL MIX STOPS
BUBBLING. SCOOP UP SLURR Y & WASH WASTE DOWN DRAIN W/EXCESS WATER.
WASH THE SITE WITH SODA ASH SOLUTION.
Neutralizing Agent:SODA ASH OR SODIUM BICARBONATE.
*Handling and Storage *
Handling and Storage Precautions:CAUTION! PROTECT FROM LIGHT. PROTECT
FROM MOISTURE. AVOID CONTACT WITH EYES, SKIN AND CLOTHING. DO NOT
BREATHE DUST. WASH THOROUGHLY AFTER HANDLING.
Other Precautions:DO NOT BREATH CHEMICALS.
* Physical/Chemical Properties *
HCC:C1
pH:1.5@5% SOLN
Solubility in Water:SOLUBLE
Appearance and Odor:WHITE POWDER; NO ODOR.
Corrosion Rate:SUPDAT
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
CONTAMINATION WITH PHOSPHATES, CONTACT WITH OXIDIZERS, DYES, ALKALIES,
IRON OR COPPER.
Stability Condition to Avoid:HEAT, FLAMES, EXPOSURE TO LIGHT OR
MOISTURE.
Hazardous Decomposition Products:MAY EMIT TOXIC FUMES OF SULFUR OXIDES
IN FIRE.
* Toxicological Information*
Toxicological Information:TOXIC DUE TO CORROSIVITY.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL FEDERAL, STATE
AND LOCAL REGULATIONS.
* MSDS Transport Information *
Transport Information:PSN: CORROSIVE SOLID, N.O.S (POTASSIUM
*
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WHEN AIRBORNE CONCENTRATION EXCEEDS TLV OR UPPER
RESPIRATORY TRACT IRRITATION OCCURS, USE NIOSH APPROVED ORGANIC
VAPOR CHEMICAL CARTRIDGE RESPIRATOR.
Ventilation:USE EXPLO-PROOF VENT TO PVNT VAP ACCUM. EMPTY CNTNRS MAY
CNTN HAZ PROD RESIDUES. FIXED EQUIP AS WELL AS TRANSFER(SUPDAT)
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
ARE FORMED FROM INCOMPLETE COMBUST. EMITS ACRID FUMES. HNDLG/STOR
WILL EXTEND PROD SHELF LIFE. VENT: CNTNRS & EQUIP SHOULD BE
GROUNDED TO PREVENT ACCUM OF STATIC DISCHARGE.
* Product Identification *
CAGE:GWXLX
CAGE:GWXLX
* Composition/Information on Ingredients *
6.1%.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: OVEREXP MAY PRDCE DROWSINESS,
WEAK UNSTEADY GAIT, NARCOSIS. SKIN CONTACT: RPTD/PRLNGD CONTACT MAY
CAUSE DERMATITIS. SKIN ABSORPTION DOES NOT OCCUR. EYES: CONTACT
W/LIQ OR VAP MAY CAUSE IRRIT W/ CORNEAL INJURY. MAY CAUSE
LACRIMATION (TEARS). INHAL: CAN CAUSE IRRIT OF RESP TRACT, NARCOSIS
& POSS (EFTS OF OVEREXP)
Effects of Overexposure:HLTH HAZ: LUNG DAMAGE. INGEST: CAN CAUSE
PRONOUNCED IRRIT OF MOUTH, ESOPHAGUS & STOMACH. IRRITANCY: PROD
EXPECTED TO BE IRRITATING TO SKIN, EYES & THROAT. SENSIT: NOT
PREDICTED TO BE SKIN SENSITIZER. TERATOGENICITY, MUTAGENICITY
EFTS: NOT AVAILABLE. REPRO EFTS OF MATL: ON TEST ANIMALS MAY CAUSE
ADVERSE REPRO EFTS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:SKIN: WASH W/SOAP & WATER. SEEK MED ATTN IF IRRITATION
IRRITATION PERSISTS, OBTAIN MED ATTN. INHAL: REMOVE TO FRESH AIR.
GIVE OXYGEN O R ARTIFICIAL RESPIRATION AS REQUIRED. OBTAIN MED
ATTN. INGEST: DO NOT INDUCE VOMITING. SEEK MED ATTN. IF VOMITING
OCCURS SPONTANEOUSLY, KEEP HEAD BELOW HIPS TO PREVENT ASPIRATION OF
LIQUID INTO LUNGS.
* Fire Fighting Measures *
Flash Point Method:PMCC
Lower Limits:SEE ING 1
Upper Limits:SEE ING 1
Extinguishing Media:FOAM, DRY CHEMICAL OR CARBON DIOXIDE, WATER FOG,
ALCOHOL FOAM.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:DIVISION 2 FLAMMABLE LIQS; MODERATE FLAM
WHEN EXPOSED TO FLAMES. SENSITIVE TO STATIC DISCHARGE. CARBON
MONOXIDE & CARBON DIOXIDE ARE PRDCED ON COMBUST. (SUPDAT)
* Accidental Release Measures *
Spill Release Procedures:REMOVE IGNITION SOURCES. VENTILATE AREA.
ABSORB W/INERT MATERIAL SUCH AS VERMICULITE, SAND OR EARTH. PLACE
IN CLOSED CONTAINER, WASH AREA W/WATER & TRISODIUM PHOSPHATE -
TREAT AS FLAMMABLE. THE VAPOR CAN TRAVEL ALONG GROUND & ACCUMULATE
INLOW AREAS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:AVOID DIRECT SUNLIGHT. AVOID ALL
CONTACT W/SKIN OR EYES. STORE AWAY FROM HEAT & OXIDIZING AGENTS IN
WELL VENTD AREA. PROTECT CNTNRS FROM (SUPDAT)
Other Precautions:DO NOT SMOKE IN AREAS OF STORAGE OR USE. AVOID
CONTACT W/SKIN & EYES. WEAR APPROPRIATE PROTECTIVE EQUIPMENT.
STYRENE VAPOR IS UNINHIBITIED & MAY POLYMERIZE, POSSIBLY BLOCKING
EXHAUST VENTS.
* Physical/Chemical Properties *
Boiling Pt:B.P. Text:SUPDAT
Vapor Pres:4.5
Vapor Density:SEE ING 1
Evaporation Rate & Reference:<1 (BUTYL ACETATE=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:VISCOUS RED-PURPLE LIQUID; AROMATIC ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:NO
ACID, BASE, OXIDIZING MATERIALS, ALUMINUM CHLORIDE.
Stability Condition to Avoid:UNSTABLE AT HIGH TEMPERATURES. KEEP VAPOR
AWAY FROM POSSIBLE IGNITION.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
ALDEHYDES. EMITS ACRID FUMES.
* Disposal Considerations *
Waste Disposal Methods:CONSULT FEDERAL, STATE AND LOCAL AUTHORITIES
CONCERNING THE DISPOSAL OF THE WASTE.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR AS REQUIRED
IF ABOVE PEL/TLV OR SCBA IN AN ENCLOSED AREA.
Ventilation:LOCAL/GENERAL TO MAINTAIN PEL/TLV.
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER,WORK
CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
AVOID PROLONGED OR REPEATED EXPOSURE. DO NOT GET ON SKIN OR IN EYES. DO
NOT BREATHE VAPORS OR MISTS.
* Product Identification *
Preparer's Name:JACK L.SHENEBERGER
* Composition/Information on Ingredients *
Ingred Name:TOLUENE (SARA III)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Effects of Overexposure:INHAL:ANSTHSA, HEADACHE;SKIN/EYE:IRRIT;
INGEST:NAUSEA
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF AILMENTS
OR WITH A PRE-EXISTING DISEASE INVOLVING THE EYES, SKIN, OR
RESPIRATORY TRACT MAY BE AT INCREASED RISK FROM EXPOSURE.
* First Aid Measures *
First Aid:INHALATION:REMOVE TO FRESH AIR. RESUSCITATE IF NOT BREATHING.
GET MEDICAL ATTENTION. EYES:IMMEDIATELY FLUSH WITH PLENTY OF WATER
SKIN:REMOVE CONTAMINATED CLOTHING. WASH WITH SOAP AND WATER. IF
IRRITATION PERSISTS, GET MEDICAL ADVICE. INGESTION:DO NOT INDUCE
VOMITING. GIVE NOTHING BY MOUTH IF UNCONSCIOUS. GET IMMEDIATE
MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point Method:CC
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:NONE REPORTED BY MFG.
* Accidental Release Measures *
Spill Release Procedures:USE PROPER PERSONAL PROTECTION;CONTAIN FREE
MATERIAL IF POSSIBLE;USE SUITABLE INERT ABSORBENT MATERIAL AND
RECOVER FOR PROPER DISPOSAL IN AN APPROVED CONTAINER.
Neutralizing Agent:NOT APPLICABLE.
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL, DRY, WELL VENTILATED
AREA. KEEP CONTAINERS TIGHTLY CLOSED WHEN NOT IN USE. PROTECT
CONTAINERS FROM PHYSICAL DAMAGE.
Other Precautions:DO NOT TAKE INTERNALLY. DO NOT BREATHE MIST. AVOID
PROLONGED OR REPEATED BREATHING OF VAPOR. AVOID CONTACT WITH EYES.
USE WITH ADEQUATE VENTILATION. WASH THOROUGHLY AFTER HANDLING.
* Physical/Chemical Properties *
HCC:F2
Vapor Density:>1.0
Evaporation Rate & Reference:<1 (ETHER=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:SLIGHTLY COLORED LIQUID, AROMATIC SOLVENT ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIALS
Hazardous Decomposition Products:SILICON OXIDE,CARBON MONOXIDE, CARBON
DIOXIDE AND OTHER UNIDENTIFIED COMPONENTS.
* Disposal Considerations *
Waste Disposal Methods:CONSULT LOCAL AUTHORITIES.DISPOSAL MUST BE MADE
IN ACCORDANCE WITH ALL APPLICABLE FEDERAL, STATE AND LOCAL LAWS AND
REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Ventilation:LOCAL EXHAUST
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH HANDS THOROUGHLY AFTER EVERY USAGE.
Supplemental Safety and Health
* Product Identification *
Preparer's Name:S. ABDUL RAZZAK
* Composition/Information on Ingredients *
Ingred Name:PHENOL,CARBOLIC ACID SOLUTION
Other REC Limits:5 MG/CUM
Ingred Name:DIETHYLENETRIAMINE, ETHYLENEDIAMINE, N-(2-AMINOETHYL)
Fraction by Wt: <5%
Other REC Limits:4 MG/CUM
OSHA PEL:1 PPM (SKIN)
ACGIH TLV:1 PPM (SKIN)
Fraction by Wt: <5%
Ingred Name:FURFURYL ALCOHOL
Fraction by Wt: <5%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: BURNS. SKIN: BURNS,
SENSITIZATION, ABSORPTION, OR OTHER ALLERGIC RESPONSES. INHALATION:
RESPIRATORY TRACT IRRITATION, NAUSEA, & VOMITING.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES: BURNS. SKIN: ABSORPTION, SENSITIZATION, &
BURNS. INHALATION: RESPIRATORY TRACT IRRITATION, NAUSEA, &
VOMITING.
Medical Cond Aggravated by Exposure:ALLERGY, ECZEMA, & SKIN CONDITIONS.
* First Aid Measures *
REMOVE TO FRESH AIR. IF BREATHING IS DIFFICULT, ADMINISTER OXYGEN.
IF BREATHING STOPS, ADMINISTER ARTIFICIAL RESPIRATION. INGESTION:
IF CONSC IOUS, GIVE PLENTY OF WATER & INDUCE VOMITING. NEVER GIVE
ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. OBTAIN MEDICAL
ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Flash Point Method:PMCC
Extinguishing Media:FOAM, CO2, OR DRY CHEMICAL
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS.
* Accidental Release Measures *
Spill Release Procedures:SOAK UP W/INERT MATERIAL OR SCRAPE UP. COLLECT
IN DESIGNATED CONTAINERS. FLUSH CONTAMINATED AREA W/WATER.
*Handling and Storage *
Handling and Storage Precautions:KEEP TUBES TIGHTLY CLOSED WHEN NOT IN
USE. USE ADEQUATE VENTILATION.
Other Precautions:AVOID PERSONAL CONTACT. AVOID BREATHING VAPORS. NEVER
MIXT W/OXIDIZERS OR EPOXY RESINS IN QUANTITIES OVER ONE POUND.
* Physical/Chemical Properties *
Solubility in Water:SLIGHT
Appearance and Odor:BEIGE W/AMINE ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, ACIDS
Stability Condition to Avoid:HEAT & OPEN FLAMES
Hazardous Decomposition Products:CO, CO2, NITROGEN OXIDES, & OTHER
TOXIC PRODUCTS
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:SELF-CONTAINED NIOSH RESPIRATOR IF TLV IS
EXCEEDED.
Ventilation:LOCAL EXHAUST
Other Protective Equipment:EYE BATH AND SAFETY SHOWER.
Supplemental Safety and Health
* Product Identification *
Product ID:PAINT, OIL, ALKYD, BROWN
* Composition/Information on Ingredients *
Ingred Name:PETROLEUM DISTILLATES (NAPHTHA OR RUBBER SOLVENT)
Ingred Name:ALKYD RESIN
* Hazards Identification *
Effects of Overexposure:SEVERE EYE IRRITATION, DRYING OF SKIN.
EXCESSIVE INHALATION CAUSES HEADACHE, DIZZINESS, NAUSEA.
* First Aid Measures *
First Aid:EYES: FLUSH WITH WATER. SKIN: WASH WITH MILD SOAP AND WATER
AND APPLY SKIN CREAM. INHALATION-REMOVE TO FRESH AIR AND CALL
PHYSICIAN. APPLY ARTIFICIAL RESPIRATION IF NECESSARY.
* Fire Fighting Measures *
Lower Limits:0.8
Upper Limits:5.0
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL
Fire Fighting Procedures:TREAT AS CLASS B FIRE
Unusual Fire/Explosion Hazard:VAPORS MAY FORM EXPLOSIVE MIXTURES WITH
AIR
* Accidental Release Measures *
Spill Release Procedures:WEAR A RESPIRATOR. FLUSH WITH WATER INTO
RETAINING AREA OR CONTAINER. AVOID EXPOSUREO SPARKS, FIRE OR HOT
METAL SURFACES.
*Handling and Storage *
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS, OPEN
FLAME. USE WITH ADEQUATE VENTILATION. AVOID PROLONGED OR REPTED
SKIN CONTACT.
* Physical/Chemical Properties *
HCC:F4
Vapor Density:4.9
Evaporation Rate & Reference:0.1, BUAC=1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BROWN OPAQUE LIQUID, PETROLEUM DISTILLATE ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Stability Condition to Avoid:EXCESSIVE HEAT, SPARKS, OPEN FLAME
Hazardous Decomposition Products:CARBON MONOXIDE
* Disposal Considerations *
Waste Disposal Methods:LANDFILL, INCINERATION UNDER SAFE AND
SUPERVISEDCONDITIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE NEEDED IN NORMAL USE W/ PROPER VENT.IN
POORLY VENT AREAS USE NIOSH APPROVED ORGANIC VAPOR MASK.
Ventilation:LOCAL EXHAUST IS RECOMMENED FOR PROLONGED/REPEATED USE.
EFFECTIVE MECH VENT IS ADEQUATE FOR OCCASIONAL USE.
Other Protective Equipment:PROTECTIVE CLOTHING SKIN CONTACT
Work Hygienic Practices:OBSERVE GOOD WORK HYGIENIC PRACTICES
Supplemental Safety and Health
(DETA). KEY1:N1.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:DIETHYLENE TRIAMINE
Fraction by Wt: <5%
Other REC Limits:
OSHA PEL:1 PPM
Ingred Name:TETRAETHYLENEPENTAMINE (TEPA)
Other REC Limits:
OSHA PEL:
ACGIH TLV:
Ingred Name:TALL OIL FATTY ACIDADDUCT OF TEPA
Other REC Limits:
OSHA PEL:
ACGIH TLV:
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYES:SEVERE IRRITATION OR
BURNS.SKIN:SEVERE IRRIT OR BURN POSSIBLE ALLERGIC
RESPONSE.INHAL:RESP IRRIT.POSSIBLE ALLERGIC
RESPONSE.CHRONIC:POSSIBLE SENSITIZATION FROM PROLONGED OR REPEATED
EXPOSUR E.
Explanation of Carcinogenicity:N/A
Effects of Overexposure:SEE HEALTH HAZ (ACUTE & CHRONIC)
Medical Cond Aggravated by Exposure:ASTHMA BRONCHITIS
* First Aid Measures *
PHYSICIAN.SKIN:REMOVE CONTAM CLOTHING.WASH W/ SOAP & H*2O.INGEST:DO
NOT INDUCE VOMITING.ADMINISTER LG AMTS OF H*2O OR MILK & TRANSPORT
TO A MEDICAL FACILITY.INHAL:REMOVE TO FRESH AIR CONTACT A
PHYSICIAN IF SYMPTOMS PERSIST.
* Fire Fighting Measures *
Flash Point Method:TCC
Extinguishing Media:CO*2 DRY CHEMICAL,FOAM WATER
Fire Fighting Procedures:DILUTION W/ LG VOLUMES OF H*2O WILL REDUCE THE
INTENSITY OF FLAMES WEAR SCBA
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
Spill Release Procedures:PREVENT SKIN & EYE CONTACT REMOVE CONTAM
CLOTHING.DISCARD CONTAM LEATHER ARTICLES SUCH AS SHOES & BELTS,
ABSORB SPILLAGE ON INERT MAT & DISCARD IN SUITABLE CONTAINERS.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:KEEP HANDS AWAY FROM EYES WHEN HAND
MAT/BEFORE WASH AFT USE. WASH THOROUGHLY BEFORE EAT/SMOKING.STORE
IN A COOL DRY PLACE.
Other Precautions:PROLONGED/REPEATED OVEREXPOSURE MAY CAUSE
SENSITIZATION & ALLERGIC RESPONSE PERSONS SO EFFECTED SHOULD
CONSULT A PHYS.IF SENSITIZATION IS CONFIRMED AVOID FURTHER EXPOSURE
TO MAT.
* Physical/Chemical Properties *
HCC:N1
Melt/Freeze Pt:M.P/F.P Text:
Decomp Temp:Decomp Text:
Vapor Pres:<1
Vapor Density:3.5
Evaporation Rate & Reference:N/A(MFR)
Solubility in Water:APPRECIABLE
Appearance and Odor:BROWN LIQUID;AMMONIA LIKE ODOR
Percent Volatiles by Volume:0
Corrosion Rate:
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZIN AGENTS,ACIDS & CHLORINATED ORGANIC COMPOUNDS
Stability Condition to Avoid:EXPOSURE TO OPEN FLAMES OR EXCESSIVE HEAT
Hazardous Decomposition Products:OXIDES OF NITROGEN,CARBON & AMMONIA
Conditions to Avoid Polymerization:HEAT IS GENERATED WHEN MIXED W/
EPOXY RESIN.USE CAUTION WHEN MIXING QUANTITIES
* Disposal Considerations *
Waste Disposal Methods:REMOVE TO A WASTE DISPOSAL FACILITY OPERATING IN
COMPLIANCE W/ STATE & LOCAL REGS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WHEN EXCESSIVE VAPOR IS LIKELY IN BREATHING
ZONE, USE NIOSH APPROVED CARTRIDGE FOR ORGANIC VAPOR.
Ventilation:ADEQUATE
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
PHYSICIAN: ACTIVATE CHARCOAL SLURRY MAY BE ADMINISTERED. TO PREPARE
AN AVERAGE ADULT.
* Product Identification *
CO.
* Composition/Information on Ingredients *
Ingred Name:GLYCOL ETHERS, DIETHYLENE GLYCOL, 2,2-OXYBISETHANOL
Ingred Name:POLYOXYALKYLENES COPOLYMER
Ingred Name:FLATTING AGENT
Fraction by Wt: 1-5%
Ingred Name:PROPRIETARY COMPONENTS
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN: IRRITATION. INGESTION: LOW
TOXICITY. INHALATION: MILD UPPER RESPIRATORY IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SKIN: IRRITATION. EYES: IRRITATION
W/DISCOMFORT, TEARING, OR BLURRING VISION. INHALATION: NONSPECIFIC
DISCOMFORT SUCH AS DIARRHEA OR WEAKNESS, TEMPORARY LUNG IRRITATION
W/COUGH, DIFFICULTY BREATHING O R SHORTNESS OF BREATH.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE
ARTIFICIAL RESPIRATION. IF BREATHING IS DIFFICULT, GIVE OXYGEN.
SKIN: FLUSH W/WATER. EYES: IMMEDIATELY FLUSH W/PLENTY OF WATER FOR
GIVE 2 GLASSES OF WATER. NEVER GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS PERSON. OBTAIN MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Extinguishing Media:USE MEDIA APPROPRIATE FOR SURROUNDING MATERIAL.
Fire Fighting Procedures:EVACUATE PERSONNEL TO A SAFE AREA. KEEP
PERSONNEL REMOVED & UPWIND OF FIRE. WEAR SELF-CONTAINED BREATHING
APPARATUS.
* Accidental Release Measures *
Spill Release Procedures:USE APPROPRIATE EQUIPMENT. DIKE SPILL. PREVENT
FROM ENTERING SEWERS, WATERWAYS OR LOW AREAS. SOAK UP W/SAWDUST,
SAND, OIL DRY, OR OTHER ABSORBENT MATERIAL. SHOVEL OR SWEEP UP.
REVIEW SAFETY PRECAUTION S BEFORE CLEANUP.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED. DON'T
STORE OR CONSUME FOOD, DRINK, OR TOBACCO IN AREAS WHERE THEY MAY
BECOME CONTAMINATED W/THIS MATERIAL.
Other Precautions:USE ONLY W/ADEQUATE VENTILATION. CLOSE CONTAINER
AFTER EACH USE. AVOID BREATHING VAPORS OR MIST. AVOID CONTACT
W/EYES, SKIN, OR CLOTHING.
* Physical/Chemical Properties *
pH:6-8
Solubility in Water:<1%
Appearance and Odor:CLOUDY WHITE LIQUID W/BLAND ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Hazardous Decomposition Products:CO, CO2
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF W/SOLID WASTE ACCORDING TO FEDERAL,
STATE, & LOCAL REGULATIONS. FLUSH SPILL AREA W/WATER. TREATMENT,
STORAGE, TRANSPORTATION, & DISPOSAL MUST BE IN ACCORDANCE
W/APPLICABLE FEDERAL, STATE, P ROVINCIAL, & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NOT REQUIRED WITH GOOD INDUSTRIAL VENTILATION.
Ventilation:LOCAL EXHAUST RECOMMENDED.
Other Protective Equipment:AS NEEDED TO PROTECT SKIN AND CLOTHING.
Supplemental Safety and Health
* Product Identification *
Kit Part:Y
* Composition/Information on Ingredients *
Ingred Name:EPOXY RESIN SYSTEM
Fraction by Wt: NA
Other REC Limits:NONE SPECIFIED
Ingred Name:SILICA
Other REC Limits:NONE SPECIFIED
ACGIH TLV:0.1 MG/M3
Ingred Name:ALUMINUM (SARA III)
Other REC Limits:NONE SPECIFIED
Other REC Limits:NONE SPECIFIED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE SKIN IRRITATION AND POSSIBLE
ALLERGIC REACTIONS. PROLONGED AND REPEATED CONTACT MAY CAUSE
SENSITIZATION WHICH WILL RESULT IN ALLERGIC REACTIONS.
Effects of Overexposure:SKIN RASH, IRRITATION.
Medical Cond Aggravated by Exposure:NA
* First Aid Measures *
First Aid:FLUSH SKIN AND EYE CONTACT WITH PLENTY OF WATER. WASH
THOROUGHLY WITH SOAP AND WATER, RUBBING ALCOHOL OR HAND CLEANER. DO
NOT USE SOLVENTS. REMOVE SOILED CLOTHING AND WASH BEFORE REUSE. IF
IRRITATIONPERSISTS, SEE PHYSICIAN.
* Fire Fighting Measures *
Flash Point Method:TOC
Lower Limits:NA
Upper Limits:NA
Extinguishing Media:DRY CHEMICAL OR HALON FIRE EXTINGUISHER OR WATER
SPRAY, FOAM OR FOG.
Fire Fighting Procedures:USE SELF-CONTAINED BREATHING APPARATUS WHEN
FIGHTING FIRES IN CONFINED AREAS.
Unusual Fire/Explosion Hazard:DENSE SMOKE AND TOXIC GASES MAY BE
LIBERATED.
* Accidental Release Measures *
GLASSES. SCRAPE UP & TRANSFER TO METAL CONTAINER. WIPE UP REMAINING
RESIDUE W/SOLVENTS, OBSERVE SOLVENT FLAMMABILITY CAUTIONS.
*Handling and Storage *
Handling and Storage Precautions:KEEP COOL IN ACCORDANCE WITH LABEL
INSTRUCTIONS. FOLLOW RECOMMENDED CURING SCHEDULE. STORE AT ROOM
Other Precautions:BE BONDED. FAILURE TO OBSERVE CAUTIONS MAY RESULT IN
EXCESSIVE HEAT BUILD-UP WITH THE RELEASE OF TOXIC GASES.
* Physical/Chemical Properties *
HCC:V7
Boiling Pt:B.P. Text:DECOMPOSES
Vapor Density:NIL
Spec Gravity:>1
Evaporation Rate & Reference:NIL
Solubility in Water:NIL
Appearance and Odor:VISCOUS GRAY PASTE WITH SLIGHT ODOR
Percent Volatiles by Volume:NA
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG LEWIS OR MINERAL ACIDS.
Stability Condition to Avoid:NA
Hazardous Decomposition Products:CO, NO2, ALDEHYDES, ACIDS AND
UNDETERMINED ORGANICS.
Conditions to Avoid Polymerization:AVOID MIX RESIN/CURING AGENT IN
CURING SURFACES TO
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF AS HAZARDOUS WASTE ACCORDING TO
FEDERAL, STATE AND LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESP DEVICE IN ACCORD WITH
EXPOSURE OF CONCERN
Ventilation:LOCAL
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:UNSATURATED POLYESTER
Ingred Name:STYRENE MONOMER
Ingred Name:PHOSPHONATE ESTER
Fraction by Wt: <6%
* Hazards Identification *
Effects of Overexposure:INHALATION: IRRIT TO ALL PARTS RESP TRACT. EYE:
EXTREMELY IRRIT. SKIN MODERATE IRRITATION.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR,GIVE ARTIF RESP IF NEEDED.
SKIN: WASH WITH SOAP & WATER,REMOVE CONTAMINATED CLOTH. EYE: FLUSH
SEE MD IMMED.
* Fire Fighting Measures *
Lower Limits:1.1
Upper Limits:6.1
Extinguishing Media:FOAM,CARBON DIOXIDE,DRY CHEMICAL
Fire Fighting Procedures:FIGHT LIKE A FUEL OIL FIRE
Unusual Fire/Explosion Hazard:MONOMERS WILL READILY POLYMERIZE AT ELEV
TEMPS. CLOSED CONTAINERS MAY RUPTURE VIOLENTLY
* Accidental Release Measures *
Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES. AVOID DIRECT
SKIN CONTACT AND INHALATION OF VAPORS. USE ABSORBENT MATERIALS LIKE
PERLITE AND VERMICULITE
*Handling and Storage *
Handling and Storage Precautions:STORE AWAY FROM HEAT AND SUNLIGHT.
MAINTAIN ADEQUATE SEPARATION FROM CATALYSTS AND PROMOTERS.
* Physical/Chemical Properties *
HCC:F4
Vapor Pres:<5
Vapor Density:3.6
Evaporation Rate & Reference:<1 (BUTYL ACETATE)
Solubility in Water:SLIGHT
Appearance and Odor:CLEAR LIQUID WITH MILD ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
HANDLING EQUIP MUST BE RESIST TO MONOMER OR ORGANIC CHEM CON
Stability Condition to Avoid:FLAMMABLE LIQUID.
Conditions to Avoid Polymerization:MIXING PROMOTERS & CATALYSTS
TOGETHER,MIX INTO PROD SEPERATE
* Disposal Considerations *
Waste Disposal Methods:CONAINERIZE WASTE FOR DISPOSAL. DISPOSE OR
RECYCLE WASTE MATERIALS IN ACCORDANCE WITH,LOCAL,STATE AND FEDERAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:SHOULD NOT BE NECESSARY UNDER NORMAL CONDITIONS.
IF EXPOSED TO VAPORS THAT EXCEED TLV OR PEL, WEAR A NIOSH APPROVED
VAPOR RESPIRATOR.
Ventilation:GOOD LOCAL MECHANICAL VENTILATION SHOULD BE SUFFICIENT.
Other Protective Equipment:ANSI APPROVED EMERGENCY EYEWASH AND DELUGE
SHOWER . WEAR PROTECTIVE CLOTHING AS NECESSARY TO PREVENT SKIN
CONTACT.
Work Hygienic Practices:WASH THOROUGHLY AFTER USE.
Supplemental Safety and Health
WASTE DISP METH: AGENCIES TO ASCERTAIN PROPER DISP PROCEDURES.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:THIOSULFURIC ACID, DIAMMONIUM SALT; (AMMONIUM THIOSULFATE)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SODIUM SULFITE
Fraction by Wt: 1-5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ACETIC ACID (CERCLA)
Fraction by Wt: 1-5%
Ingred Name:WATER
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION: LOW HAZARD FOR
ORDINARY INDUSTRIAL HANDLING. EYES: CONTACT MAY CAUSE IRRITATION.
SKIN: REPEATED AND PROLONGED CONTACT MAY CAUSE IRRITATION.
INGESTION: DO NOT TAKE INTERNALLY. MAY BE HARMFUL IF SWALLOWED.
CHRONIC: NONE SPECIFIED BY MANUFACTURER.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
MINUTES. SEEK MEDICAL ATTENTION. SKIN: WASH WITH SOAP AND WATER. IF
IRRITATION OCCURS, SEEK MEDICAL ATTENTION. INGESTION: INDUCE
VOMITING. SEEK MEDICAL ATTENTION IMMEDIATELY GIVING FULL DETAILS
OF AMOUNT INGESTED AND TOXICITY. INHALATION: MOVE TO FRESH AIR.
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:USE METHOD APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:WHEN HEATED TO DECOMPOSITION, IT CAN EMIT
TOXIC FUMES OF SO*X AND AMMONIA.
* Accidental Release Measures *
Spill Release Procedures:WEAR PROTECTIVE CLOTHING AS SPECIFIED.
NEUTRALIZE WITH SODIUM BICARBONATE. IF FEDERAL, STATE AND LOCAL
LAWS PERMIT, FLUSH TO SEWER WITH LARGE AMOUNTS OF WATER.
Neutralizing Agent:SODIUM BICARBONATE.
*Handling and Storage *
Handling and Storage Precautions:DO NOT STORE OR CONSUME FOOD, DRINK OR
TOBACCO IN SURROUNDING AREA.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
* Physical/Chemical Properties *
Vapor Density:0.6
pH:4.6
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, SLIGHT VINEGAR ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
MINERAL ACIDS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:WHEN HEATED TO DECOMPOSITION, IT CAN
EMIT TOXIC FUMES OF SO*2, CARBON DIOXIDE AND POSSIBLY CARBON
MONOXIDE.
* Disposal Considerations *
Waste Disposal Methods:NEUT W/SODIUM BICARBONATE. IF FED, STATE &/LOC
LAWS PERMIT, FLUSH TO SEWER W/LGE AMTS OF WATER. OTHERWISE DISP OF
CONTAM PROD & MATLS USED IN CLEANING UP SPILL IN A MANNER APPRVD
FOR THIS MATL. CONSUL T PROPER FED, STATE &/LOC REGULATORY (SUP
DAT)
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE KNOWN.
Ventilation:NONE KNOWN.
Other Protective Equipment:NONE KNOWN.
Work Hygienic Practices:NONE KNOWN.
Supplemental Safety and Health
* Product Identification *
CAGE:0PGK2
* Composition/Information on Ingredients *
Ingred Name:DIMETHYLPOLYSILOXANE
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INGESTION, SKIN CONTACT, INHALATION:
NO KNOWN ACUTE HEALTH HAZARDS. EYE CONTACT: MAY CAUSE MILD EYE
IRRITATION. TARGET ORGANS EFFECTS: NONE KNOWN. ATTENTION!! NOT FOR
INJECTION INTO HUMANS. THIS PRODU CT CONTAINS METHYLPOLYSILOXANES
ABOVE, IN ATMOSPHERES WHICH CONTAIN OXYGEN. FORMALDEHYDE IS A SKIN
AND RESPIRATORY SENSITIZER, EYE, AND THROAT IRRITANT, ACUTE
TOXICANT, AND POTENTIAL CANCER HAZARD.
Explanation of Carcinogenicity:THIS PRODUCT OR ONE OF ITS INGREDIENTS
PRESENT, EQUAL TO 0.1% OR MORE, IS NOT LISTED AS A CARCINOGEN OR
SUSPECTED CARCINOGEN BY NTP, IARC, OR OSHA.
Effects of Overexposure:EYE CONTACT: MILD EYE IRRITATION.
Medical Cond Aggravated by Exposure:NONE KNOWN.
* First Aid Measures *
First Aid:INGESTION, INHALATION: NONE KNOWN. SKIN: WASH WITH SOAP AND
WATER. EYES: IN CASE OF CONTACT, IMMEDIATELY FLUSH EYES WITH PLENTY
IRRITATIO N PERSISTS.
* Fire Fighting Measures *
Flash Point Method:PMCC
Autoignition Temp:Autoignition Temp Text:UNK
Extinguishing Media:ALL STANDARD FIRE FIGHTING MEDIA.
Fire Fighting Procedures:NONE KNOWN.
Unusual Fire/Explosion Hazard:SENSITIVITY TO STATIC DISCHARGE IS NOT
EXPECTED.:
* Accidental Release Measures *
Spill Release Procedures:WIPE, SCRAPE OR SOAK UP IN AN INERT MATERIAL
AND PUT IN A CONTAINER FOR DISPOSAL. WASH WALKING SURFACES WITH
DETERGENT AND WATER TO REDUCE SLIPPING HAZARD.
*Handling and Storage *
Handling and Storage Precautions:NONE KNOWN.
Other Precautions:GOOD INDUSTRIAL HYGIENE PRACTICES SHOULD BE USED IN
HANDLING PRODUCT .
* Physical/Chemical Properties *
HCC:V5
Vapor Pres:NEGLIGIBLE
VOC Pounds/Gallon:5
Evaporation Rate & Reference:<1 (BUAC=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:CLEAR, ODORLESS LIQUID.
Percent Volatiles by Volume:<1
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
FORMALDEHYDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
* Toxicological Information*
TO EYES (RBT); DERM AL SENSITIZATION: NON-SENSITIZER BY TOPICAL
OCCLUSIVE APPLICCATION IN THE GIUNEA PIG. MUTAGENICITY TESTING:
SALMONELLA TYPHIRNURIUM / MAMMALIAN MICROSOME PLATE INCORPROATION
ASSAY DID NOT SHOW MUTAGEN IC POTENTIAL, WITH AND WITHOUT METABOLIC
ACTIVATION. SKIN ABSORBTION: RESULTS OF DERMAL PENETRATION STUDIES
INDICATE VERY LITTLE ABSORBTION THROUGH THE SKIN.
* Ecological Information *
Ecological:NO DATA AT THIS TIME. CHEMICAL FATE INFORMATION: NO DATA AT
THIS TIME.
* Disposal Considerations *
Waste Disposal Methods:DISPOSAL SHOULD BE MADE IN ACORDANCE WITH
FEDERAL, STATE, AND LOCAL REGULATIONS. INCINERATION RECOMMENDED IN
APPROVED INCINERATOR ACCORDING TO STATE, FEDERAL AND LOCAL
REGULATIONS.
* MSDS Transport Information *
Transport Information:DOT, IATA, IMO IMDG-CODE, EUROPEAN CLASS: RID
(OCTI), ADR (ECE), RAR (IATA): NONE.
* Regulatory Information *
SARA Title III Information:MATERIAL; DOES NOT CONTAIN ANY SUBSTANCES ON
THE LIST OF TOXIC CHEMICALS SUBJECT TO THE FOLLOWING: SARA SECTION
CHEMICALS: NONE; CPSC CL ASSIFICATION: NONE.
Federal Regulatory Information:TSCA: MATERIAL OR ITS COMPONENTS ARE
LISTED WITH TSCA CHEMICAL SUBSTANCE INVENTORY. BY PRODUCT -
LISTED. MASSACHUSETTS SUBSTANCE LIST, PENNSYLVANIA HAZARDOUS
SUBSTANCE LIST, AND NEW JERSEY RTK HAZARDOUS LIST: NO COMPONENTS
LISTED.
* Other Information *
| 1 | eyes_protection_mandatory |
Control Measures
*
*
Contractor Summary
*
*
Ingredients
*
------------------------------
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
HYDROGEN PEROXIDE, ACETIC ANHYDRIDE.
-----------------------------
ULCERATION, LARYNGITIS, BRONCH, PNEUM &
-----------------------------
PROLONGED EXPOSURE MAY OCCUR.
-----------------------------
FOR BURNS, APPLY STERILE NON-MEDICATED
-----------------------------
VICTIM LARGE QTYS OF WATER (TO DILUTE
-----------------------------
-----------------------------
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
RESP IRRIT, COUGH, CHOKING, HDCH, DIZZ, WEAK CAN OCCUR. DELAYED SYMPS INCL
LUNG FLUID, CHEST PAINS, FROTHY SPUTUM, CYANOSIS, RALES & HYPOTENSION.
SKIN CNTCT MAY RSLT IN IRRIT, PAIN, BURNS, BLISTERS & BROWN/YELLOW
STAINS. EYE CNTCT MAY RSLT IN (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: HLTH HAZ: SWELL, IRRIT, DMG TO CORNEA
& CONJ RSLTG IN BLURRED/PARTIAL LOSS OF VISION. INGEST MAY RSLT IN SEV
BURNS OF MOUTH, THROAT & STOM; VOMIT & DIARR OF DARK BLOOD. ASPHYXIA
FROM THROAT SWELL CAN OCCUR, PERFORATIONS OF ESOPHAGUS & STOMCAN OCCUR.
CHRONIC: HAZS: SENSIT DERM FROM PRLNG EXPOS CAN OCCUR. DENTAL
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: INHAL: MOVE TO FRESH AIR, GIVE ARTF RESP IF NEC. MAINTAIN AIRWAY,
GIVE OXYGEN (MED TRAINED ONLY), MAINTAIN BLOOD PRESS. GET MED AID IMMED.
SKIN: REMOVE CONTAMD CLTHG. WASH W/SOAP & WATER, FLUSH W/LG A MTS OF
BANDAGE (SECURE NOT TIGHT). GET MED AID IMMED. EYES: WASH EYES W/LG AMTS OF
WATER, LIFTING UPPER/LOWER LIDS
*
Handling and Disposal
*
Spill Release Procedures: ABSORB LIQ W/INERT OR NEUT SUBSTANCE SUCH AS FULLER'S
EARTH, CEMENT PWDR, FLY ASH, SAND. SCOOP MATL INTO SUITABLE (PLASTIC/GLASS)
CNTNR, LABEL FOR DISP. CAUSTIC SODA MAY BE USED TO NEUT. SHUT OFF IGNI T
SOURCE, AVOID VAPS. ISOLATE, VENT SPILL AREA.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE IN ACCORDANCE WITH FEDERAL, STATE AND LOCAL
LAWS.
Handling And Storage Precautions: STORE IN ACID CONTAINMENT AREA, PROTECTED
FROM HEAT & IGNITION SOURCES. KEEP AWAY FROM OXIDIZERS, OTHER
INCOMPATIBLE MATERIALS.
Other Precautions: VAPORS HEAVIER THAN AIR. USE ADEQUATE VENTILATION. KEEP OUT
OF SEWERS AND DRAINS.
*
Fire and Explosion Hazard Information
*
Extinguishing Media: DRY CHEMICAL, CARBON DIOXIDE, WATER SPRAY OR FOAM.
Fire Fighting Procedures: USE NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP(FP
N). FLAMM CLASS II FOR GLACIAL ACETIC ACID. MOVE CNTNR IF POSS; COOL W/WATER.
AVOID BRTHG CORR VAPS, (SUPDAT)
Unusual Fire/Explosion Hazard: UNKNOWN FIRE AND EXPLOSION HAZARD AT LOWER
CONCENTRATIONS.
*
*
NIOSH/MSHA APPRVD SAF:PD,PP,CF. ESCAPE - NIOSH/MSHA APPRVD GMOV/SCBA. (RESP
Ventilation: PROVIDE LOCAL EXHAUST VENTILATION TO MEET PERMISSABLE EXPOSURE
LIMITS (PEL).
Other Protective Equipment: ANSI APPROVED EMERGENCY EYE WASH FOUNTAIN & DELUGE
SHOWER (FP N). WEAR CLOTHING IMPERVIOUS TO ACID.
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: FIRE FIGHT PROC: KNOCK DOWN W/WATER SPRAY. VAPS
HVR/AIR, MAY TRAVEL CONSIDERABLE DIST & FLASH BACK FROM SOURCE OF IGNIT.
KEEP OUT OF SEWERS & DRAINS. MATL TO AVOID: CARBINOL & OZONE, NITRIC
ACID, NITR IC ACID & ACETONE, PERCHLORIC ACID, PERMANGANATES, PHOSPHOROUS
TRICHLORIDE, SODIUM PEROXIDE, N-XYLENE,
*
Physical/Chemical Properties
*
Vapor Density: 0.7-2.1
Spec Gravity: 1.0-1.4
PH: ACID
Solubility in Water: MISCIBLE
Appearance and Odor: COLORLESS LIQUID WITH MILD TO PUNGENT VINEGAR-LIKE ODOR.
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: DANGEROUS IN CONTACT WITH OXIDIZERS. ATTACKS MOST
METALS, INCLUDING STAINLESS STEEL AND ZINC.
Materials To Avoid: EXPLO/VIOLENT RXNS W/BROMINE PENTAFLUORIDE, CHLORINE
TRIFLUORIDE, CHROMIC ACID OR ANHYDRIDE, DIALLYL METHYL (SUPDAT)
Hazardous Decomposition Products: THERMAL DECOMPOSITION MAY RELEASE TOXIC
OXIDES OF CARBON.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
HAZCOM Label
*
Assigned IND: Y
Company Name: LABCHEM INC
Label Required IND: Y
Status Code: C
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Slight
Fire Hazard: Moderate
Reactivity Hazard: None
Hazard And Precautions: COMBUSTIBLE. ACUTE: INHAL: RESPIRATORY IRRIT, COUGHING,
CHOKING, HEADACHE, DIZZINESS, WEAKNESS. DELAYED SYMPS INCL LUNG FLUID, CHEST
PAINS, FROTHY SPUTUM, CYANOSIS, RALES & HYPOTENSION. SKIN: IRRIT, P AIN,
BURNS, BLISTERS & BROWN/YELLOW SKIN. EYES: SWELLING, IRRIT, DMG TO CORNEA
& CONJUNCTIVA WITH BLURRED/PARTIAL LOSS OF VISION. INGEST: SEV BURNS OF
MOUTH, THROAT & STOMACH, VOMIT & DIARRHEA OF DARK BLOOD. ASPHYXIA
FROM THROAT SWELLING, PERFORATIONS OF ESOPHAGUS & STOMACH. CHRONIC:
SENSITIZATION DERMATITIS. DENTAL EROSION, TOOTH DISCOLORATION, JAW NECROSIS,
NASAL ULCERATION, LARYNGITIS, BRONCHIT IS, PNEUMONIA & GI DISTURBS, EYE
CONJUNCTIVITIS.
*
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:ADEQUATE VENTILATION. NIOSH APPROVED RESPIRATOR
APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:OPEN WINDOWS OR USE FAN.
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:REMOVE AND WASH CONTAMINATED CLOTHING. WASH
AFFECTED AREAS OF SKIN WITH SOAP AND WATER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
CAGE:KURFE
CAGE:KURFE
* Composition/Information on Ingredients *
Ingred Name:1,2-PROPANEDIOL; (PROPYLENE GLYCOL)
Fraction by Wt: 5-8%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CALCIUM CARBONATE
Fraction by Wt: 5-8%
Ingred Name:PROPIONIC ACID, 2-METHYL-, MONOESTER WITH 2,2,4-
TRIMETHYL-1,3-PENTANEDIOL; (ESTER ALCOHOL)
Fraction by Wt: 0.5-2%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:NONYLPHENOXYPOLYETHOXYETHANOL; (SURFACTANT)
Fraction by Wt: 0.5-2%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PIGMENT
OSHA PEL:N/K
ACGIH TLV:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: SLIGHT IRRITATION MAY RESULT
FROM EYE CONTACT. CHRONIC: NONE LISTED BY MANUFACTURER.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE.
* First Aid Measures *
First Aid:INGEST: CALL MD IMMEDIATELY . INHAL: REMOVE TO FRESH AIR.
SUPPORT BREATHING (GIVE O*2/ARTF RESP) . SKIN: FLUSH W/COPIOUS
AMOUNTS OF WATER. CALL MD . EYE CONT: IRRIGATE IMMEDIATELY AN D
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:0.6%
Extinguishing Media:FOAM, CO*2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:NONE. USE NIOSH APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
* Accidental Release Measures *
Spill Release Procedures:AVOID BREATHING VAPORS. VENTILATE AREA.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:NONE.
Other Precautions:DO NOT TAKE INTERNALLY. KEEP OUT OF REACH OF
CHILDREN.
* Physical/Chemical Properties *
Vapor Density:HVR/AIR
Evaporation Rate & Reference:FASTER THAN ETHER
Solubility in Water:NOT KNOWN
Appearance and Odor:
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:NONE.
* Disposal Considerations *
Waste Disposal Methods:CLOSED METAL CONTAINER. DISPOSAL MUST BE I/A/W
FEDERAL, STATE & LOCAL REGULATIONS .
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL AND GENERAL VENTILATION NECESSARY TO KEEP AIR
CONCENTRATION BELOW TLV .
Other Protective Equipment:N/K
Work Hygienic Practices:WASH HANDS AFTER USING.LAUNDER CONTAMINATED
CLOTHING BEFORE REUSE.
Supplemental Safety and Health
* Product Identification *
Product ID:FIN-L-WASH SURFACE CLEANER
* Composition/Information on Ingredients *
(THEORETICAL).
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:MINERAL SPIRITS.VAPOR PRESSURE:2.0.
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PROLONGED OVEREXPOSURE TO SOLVENT
INGREDIENTS MAY CAUSE ADVERSE EFFECTS TO LIVER & URINARY
SYSTEMS.REPORTS HAVE ASSOCIATED REPEATED & PROLONGED OVEREXPOSURE
TO SOLVENTS W/ PERM BRAIN & NERVOUS SYS DAM AGE.INTENTIONAL MISUSE
BY DELIBERATELY CONC & INHALING CONTENTS CAN BE HARMFUL OR
FATAL.EXTREME OVEREXPOS-UNCON,DEATH.
Explanation of Carcinogenicity:NONE
Effects of
Overexposure:EYES:IRRIT,REDNESS,ITCHING,BURNING.SKIN:IRRIT,REDNESS,
ITCHING,BURNING.INGESTION:N/K .INHALATION:RESPIRATORY SYSTEM
IRRIT.NERVOUS SYSTEM DEPRESSION.EXTREME OVEREXPOSURE POSS
UNCON,DEATH.HEAD ACHE,DIZZINESS,NAUSEA,COORDINATION LOSSINDICATION
OF EXCESS EXPOSURE TO VAPORS,SPRAY MISTS.
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.
* First Aid Measures *
MINUTES.GET MEDICAL ATTENTION.SKIN:WASH THOROUGHLY WITH SOAP &
WATER.REMOVE CONTAMINATED CLOTHING.INGESTION:NEVER GIVE ANYTHING BY
MOUTH TO AN UN CONSCIOUS PERSON.DO NOT INDUCE VOMITING.GIVE SEVERAL
GLASSES OF WATER.SEEK MEDICAL ATTENTION.INHALATION:REMOVE FROM
EXPOSURE.RESTORE BREATHING.KEEP WARM AND QUIET.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:N/K
Upper Limits:1.0
Extinguishing Media:CARBON DIOXIDE,DRY CHEMICAL,FOAM.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROT EQUIP
.WATER SPRAY POSS INEFTIVE,USE FOG NOZZ.USE WATER TO COOL CLSD
CONTR,PVNT PRESS BUILDUP,AUTOIGNIT,EXPLO.
Unusual Fire/Explosion Hazard:KEEP CONTR TIGHTLY CLSD.KEEP FROM
HEAT,ELEC EQUIP,SPKS,OPEN FLAME.CLSD CONTR MAY EXPLODE IN HEAT.HOT
SURF APPLICATN-SPEC PREC NEC.DECOMP PROD OVEREXPO (SUP DA)
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION.VENTILATE AND
REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:N/K
*Handling and Storage *
Handling and Storage Precautions:COMBUST.KEEP FROM HEAT,OPEN
FLAME.CONSULT NFPA CODE.USE APPRVD BONDING,GROUNDING PROC.DOL STOR
CATEGORY 2.USE W/ ADEQ VENT.AVOID SKIN/EYE CONTACT.
Other Precautions:KEEP CONTR CLSD WHEN NOT IN USE.TRANSFER ONLY TO
APPROVED CONTR W/ COMPLETE,APPROP LABELING.DO NOT TAKE
INTERNALLY.KEEP OUT OF REACH OF CHILDREN.INTENTIONAL MISUSE BY
CONCENTRATING,INHALING CONTENTS H ARMFUL/FATAL.AVOID BRTHG
VAP/SPRAY MIST.
(MFR),INGESTION .
* Physical/Chemical Properties *
Boiling Pt:B.P. Text:SEE SUPP
Melt/Freeze Pt:M.P/F.P Text:N/K
Decomp Temp:Decomp Text:N/K
Vapor Pres:N/K
Vapor Density:>1 (AIR=1)
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:N/K
Appearance and Odor:N/K
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
N/K
Stability Condition to Avoid:N/K
Hazardous Decomposition Products:BY FIRE:CARBON DIOXIDE,CARBON
MONOXIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
* Disposal Considerations *
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH
FEDERAL,STATE AND LOCAL REGULATIONS .INCINERATE IN APPROVED
FACILITY.DO NOT INCINERATE CLOSED CONTR.MAY BE HAZARDOUS PER RCRA
NUMBERS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:MATERIAL SHOULD BE HANDLED/TRANSFERRED IN AN APPROVED FUME
HOOD OR WITH ADEQUATE VENTILATION.
Other Protective Equipment:EMERGENCY EYEWASH & DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA .
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
SPILL PROC:CNTNERIZE FOR PROPER DISP. COMPLY W/FED, STATE & LOC REGS ON
REPORTING QTY & OTHER REG DATA. EM SCIENCE RECOMMS SPILL-X NEUT &
ABSORB AGENTS FOR VARIOUS TYPES OF SPILLS. ADDTNL INFO ON SPIL L-X
* Product Identification *
* Composition/Information on Ingredients *
Fraction by Wt: 0.1%
OSHA PEL:0.2 MG/M3 DUST; Z-2
Fraction by Wt: 5%
OSHA PEL:2 PPM
ACGIH TLV:2 PPM; 4 STEL
Ingred Name:WATER
Ingred Name:EXPLAN OF CARCIN: BE CARCINOGEN. HUMAN: LUNG, PROSTATE,
RENAL SYSTEM EFFECTS.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:MAY BE HARMFUL IF SWALLOWED.
IRRITATING TO EYES & MUCOUS MEMBRANES. MAY CAUSE EYE INJURY. VAPOR
IRRITATING TO EYES & RESPIRATORY PASSAGES. MAY BE IRRITATING ON
CONTACT W/SKIN.
TO (ING 4)
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:RESPIRATORY CONDITIONS.
* First Aid Measures *
First Aid:GET MEDICAL ASSISTANCE FOR ALL CASES OF OVEREXPOSURE. SKIN:
IMMEDIATELY FLUSH THOROUGHLY WITH LARGE AMOUNTS OF WATER. EYES:
INHALATIO N: REMOVE TO FRESH AIR; GIVE ARTIFICIALRESPIRATION IF
BREATHING HAS STOPPED. INGEST: GET IMMEDIATE MEDICAL ATTENTION; IF
CONCIOUS, GIVE WATER FREELY.
* Fire Fighting Measures *
Flash Point:NONCOMBUSTIBLE
Extinguishing Media:USE ANY SUITABLE FOR ADJACENT MATERIAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SELF-CONTAINED
BREATHING APPARATUS AND FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:THERMAL DECOMPOSITION PRODUCES TOXIC
FUMES.
* Accidental Release Measures *
Spill Release Procedures:EVAC AREA OF ALL UNNEC PERS. WEAR SUIT PROT
EQUIP LISTED UNDER EXPOSURE/PERS PROT. ELIM ANY IGNIT SOURCES UNTIL
AREA IS DETERMINED TO BE FREE FROM EXPLOS/FIRE HAZ. CONTAIN RELEASE
& ELIM ITS SOURCE, I F THIS CAN BE DONE W/OUT RISK. TAKE UP & (SUP
DAT)
ACID SPILL TREATMENT KIT.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER CLOSED. STORE AT
CONTROLLED ROOM TEMPERATURE. DO NOT BREATHE VAPOR.
Other Precautions:DO NOT GET IN EYES, ON SKIN OR ON CLOTHING. DO NOT
TAKE INTERNALLY.
* Physical/Chemical Properties *
Solubility in Water:SOLUBLE
Appearance and Odor:CLEAR LIQUID.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:EXTREME HEAT.
Hazardous Decomposition Products:NO*X.
* Disposal Considerations *
TECHNOLOGY - CONTACT LOCAL PERMITTED WASTE DISPOSAL SITE (TSD) FOR
PERMISSIBLE TREATMENT SITES. ALWAYS CONTACT PERMITTED WASTE DISP
(TSD) TO ASSURE COMPLI ANCE WITH ALL CURRENT LOCAL, STATE & FEDERAL
REGS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:SUPPLIED AIR W/FULL FACEPIECE,HELMET OR HOOD
Ventilation:LOCAL EXHAUST
Other Protective Equipment:FULL CLOTHING TO PREVENT SKIN CONTACT
Supplemental Safety and Health
OVEREXPOS:CAN CAUSE FORMATION OF CYSTS,CAUSES STILLBIRTHS.IRRITATES
EYES,NOSE THROAT.
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:POLYCHLORINATED BIPHENYLS (PCBS) (SARA III)
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
* Hazards Identification *
Effects of Overexposure:ABSORBED THRU SKIN,LUNGS,INTESTINE.CAUSES
CANCER,LIVER,KIDNEY,STOMACH,EYE,HEARING DISORDER(SUP DATA)
* First Aid Measures *
First Aid:EYES:FLUSH W/WATER IMMEDIATELY.SKIN:WASH W/SOAP
IMMEDIATELY.INHAL:REMOVE TO FRESH AIR,GIVER ART.RESPIR. AS
NEEDED.INGEST:GET MEDICAL ATTN.GIVE LARGE QTY OF SALT WATER,INDUCE
VOMITING,BUT DO NOT MAKE U NCONSCIOUS PERSON VOMIT.
* Accidental Release Measures *
Spill Release Procedures:USE ABSORBENT & DIKES TO PREVENT
RUNOFF.ISOLATE & NOTIFY PROPER AUTHORITIES.
*Handling and Storage *
Handling and Storage Precautions:STORAGE MUST FOLLOW RCRA REQUIREMENTS.
* Physical/Chemical Properties *
HCC:Z3
Appearance and Odor:LIGHT STRAW-COLORED LIQUID,AROMATIC ODOR
* Stability and Reactivity Data *
STRONG OXIDIZERS
* Disposal Considerations *
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-GENERALLY HIGH
TEMPERATURE INCINERATION.ONLY APPROVED DISPOSAL OPERATOR PERMITTED.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:SCBA IF INVOLVED IN FIRE, OTHERWISE GAS MASK.
Ventilation:PROVIDE MECHAN(GEN/LOCAL EXHAUST)VENT TO MAINTN <TLV
Other Protective Equipment:EYE WASH STATION. APRONS. SPECIAL IMPERVIOUS
CLOTHING.
Supplemental Safety and Health
BY DGSC-STF.
* Product Identification *
* Composition/Information on Ingredients *
* Hazards Identification *
Effects of Overexposure:HAZ DEGREE DEPENDS ON TYPE/QUANT OF RADIATION.
LATENT EFFECTS:SOMATIC/GENETIC DAMAGE.
* First Aid Measures *
First Aid:USE FIRST AID. CALL MEDICAL EMERGENCY CARE. REMOVE/ISOLATE
COMTAMINATED CLOTHING.SHOWER VICTIM(S) W. SOAP & H*2O. DETAIN
PERSONNEL/EQUIPMENT EXPOSED. ADVISE MEDICAL PERSONNEL THAT
VICTIM(S) MAY BE CON TAMINATED.
* Fire Fighting Measures *
Extinguishing Media:EXTINQUISH W. AGENT SUITABLE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR CHEMICAL PROTECTIVE SUIT WITH SELF CONTD
BRTHG APP.
Unusual Fire/Explosion Hazard:SOME OF MATL MAY BURN. CONT MAY EXPLODE
IN HEAT OF FIRE.
* Accidental Release Measures *
*Handling and Storage *
Handling and Storage Precautions:SHIELD ACCORDING TO EMITTED RADIATION.
PROTECT FROM FILM/FILM PLATES. KEEP CONTAINERS CLOSED. STORE IN
AREA FOR RADIOACTIVE MATERIALS.
* Physical/Chemical Properties *
HCC:A3
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
ISOLATE,SEGREGATE FROM MOST OTHER TYPE MATERIAL
Hazardous Decomposition Products:DEPENDS ON CHEMICAL COMPOSITION;
FISSION PRODUCTS
* Disposal Considerations *
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-IN ACCORDANCE WITH
DOD REGULATIONS AND FEDERAL,STATE & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESP TYPES SUITABLE FOR
INGREDIENTS RECOMMENDED. APPROVED CHEMICAL/MECHANICAL FILTERS
RECOMMENDED WHEN VENTILATION IS RESTRICTED. WEAR APPROPRIATE
RESPIRATOR UNLESS AIR MONITORING RECORDS EXPOSURES BELOW
APPLICABLE LIMIT
Ventilation:PROVIDE SUFFICIENT VENTILATION, IN VOLUME & PATTERN, TO
KEEP AIR CONTAMINENTS BELOW CURRENT APPLICABLE PEL/TLV.
Other Protective Equipment:AS REQUIRED TO AVOID WETTING CLOTHING. USE
PROTECTIVE CREAMS WHERE SKIN CONTACT LIKELY. EYE WASH & SAFETY
SHOWER.
Work Hygienic Practices:AVOID CONTACT WITH SKIN,EYES,CLOTHING. WASH
THOROUGHLY AFTER HANDLING. REMOVE & WASH CONTAMINATED CLOTHING
BEFORE REUSE.
Supplemental Safety and Health
NONE
* Product Identification *
Kit Part:Y
* Composition/Information on Ingredients *
Ingred Name:TITANIUM DIOXIDE
Other REC Limits: SPECIFIED
Ingred Name:DIATOMACEOUS EARTH, FLUX-CALCINED
Fraction by Wt: 5%
Other REC Limits: SPECIFIED
Ingred Name:HEAVY AROMATIC NAPHTHA (SOLVENT NAPHTHA)
Fraction by Wt: 5%
Other REC Limits: SPECIFIED
Ingred Name:METHYL ETHYL KETONE (2-BUTA) (MEK) (SARA III)
Other REC Limits: SPECIFIED
Ingred Name:METHYL N-AMYL KETONE
Other REC Limits: SPECIFIED
Ingred Name:EPOXY RESIN
Other REC Limits: SPECIFIED
Ingred Name:CHLORITE (A MINERAL CONSISTING OF APPROXIMATELY
Other REC Limits: SPECIFIED
Other REC Limits: SPECIFIED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:BREATHING HIGH VAPOR CONCENTRATIONS
MAY PRODUCE NARCOSIS. LIQUID MAY CAUSE MINOR SKIN IRRITATION AND
DEFINITE EYE IRRITATION. CAUSES NOSE & THROAT IRRITATION.
PROLONGED/REPEATED OVEREXPOSURE TO SOLVEN TS COULD CAUSE PERMANENT
BRAIN & NERVOUSSYSTEM DAMAGE. INTENTIONAL MISUSE BY INHALING VAPOR
MAY BE HARMFUL OR FATAL.
Explanation of Carcinogenicity:MFR LISTED NO INFORMATION ABOUT THE
CARCINOGENICITY OF THIS MATERIAL. HMIS DOES NOT EXPECT IT TO BE
CARCINOGENIC.
Medical Cond Aggravated by Exposure:UNPROTECTED EXPOSURE TO DUST LEVELS
IN EXCESS OF THE PEL MAY CAUSE LUNG DISEASE (SILICOSIS).
* First Aid Measures *
First Aid:INHALED:REMOVE TO FRESH AIR. RESTORE BREATHING. CONSULT A
PHYSICIAN. SKIN:FLUSH W/WATER. EYE:FLUSH IMMEDIATELY W/LARGE
AMOUNTS OF WATER. CONSULT PHYSICIAN. INGESTED:GET IMMEDIATE MEDICAL
MIN AND GET IMMEDIATE MEDICAL ATTENTION. FOR SKIN WASH THOROUGHLY
WITH SOAP & WATER.
* Fire Fighting Measures *
Flash Point Method:SCC
Lower Limits:1.1
Extinguishing Media:ALCOHOL FOAM, WATER FOG, DRY CHEMICAL, CARBON
DIOXIDE
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED GAS MASK FOR FIRE
FIGHTING PERSONNEL. WATER MAY BE USED TO COOL CONTAINERS. IF WATER
IS USED, FOG NOZZLES ARE PREFERRED.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. VAPORS
MAY MIGRATE TO IGNITION SOURCE & FLASH BACK. ISOLATE FROM
HEAT,SPARKS,ELECTRICAL EQUIPMENT, & ALL OTHER IGNITIION SOURCES
* Accidental Release Measures *
Spill Release Procedures:ABSORB WITH INERT MATERIAL & DISPOSE OF IN
ACCORDANCE WITH APPLICABLE REGULATIONS OF E.P.A. AND OTHER LOCAL,
STATE & FEDERAL AUTHORITIES.
Neutralizing Agent:NO INFORMATION GIVEN BY MFR ON MSDS.
*Handling and Storage *
Handling and Storage Precautions:STORE AWAY FROM HEAT, SPARKS AND OPEN
FLAME. STORE IN A COOL DRY AREA W/VENTILATION SUITABLE FOR STORING
MATERIALS SHOWN IN INGREDIENTS SECTION.
Other Precautions:DO NOT BREATHE SPRAY MIST. AVOID PROLONGED SKIN
CONTACT. GROUND CONTAINERS WHILE POURING. AVOID SPONTANEOUS
COMBUSTION OF CONTAMINATED RAGS OR OTHER ORGANIC MATERIALS. EMPTY
CONTAINERS MAY RETAIN HAZA RDOUS PROPERTIES AND CAN BE DANGEROUS.
* Physical/Chemical Properties *
HCC:F2
NRC/State Lic Num:
Vapor Density:> AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:INSOLUBLE
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:EXCESSIVE HEAT, SPARKS OR OPEN FLAME
Hazardous Decomposition Products:NO INFORMATION GIVEN BY MFR ON MSDS.
Conditions to Avoid Polymerization:WILL NOT OCCUR UNDER NORMAL
CONDITIONS.
* Disposal Considerations *
Waste Disposal Methods:PLACE IN CLOSED CONTAINERS. DISPOSE OF PRODUCT
I/A/W FEDERAL, STATE, COUNTY & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH APPROVED RESPIRATOR.
Ventilation:GOOD VENTILATION. LOCAL EXHAUST: YES. MECHANICAL (GENERAL):
YES - FOLLOW OSHA STANDARD.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:SILICA, CRYSTALLINE - QUARTZ; (SILICON DIOXIDE)
OSHA PEL:SEE TABLE Z-3
ACGIH TLV:0.1 MG/M3 RDUST
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYE IRRITATION - POSSIBLE SKIN
IRRITATION. CHRONIC:FREE SILICA DUST MAY CAUSE DELAYED LUNG INJURY.
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-QUARTZ:IARC
CARCINS, (SUPP DATA)
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NOT KNOWN.
* First Aid Measures *
First Aid:INHALATION:MOVE SUBJECT TO FRESH AIR. EYES:FLUSH W/WATER FOR
* Fire Fighting Measures *
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE . NO FIRE
HAZARD.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
* Accidental Release Measures *
Spill Release Procedures:SWEEP OR VACUUM USING GOOD VENTILATION SO TLV
IS NOT EXCEEDED.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:USE DUSTLESS SYSTEMS FOR HANDLING,
STORAGE & CLEANUP SO TLV OF SIO*2 IS NOT EXCEEDED.
Other Precautions:PRACTICE GOOD HOUSEKEEPING & POST WORK AREAS WHERE
PRODUCT IS USED.
* Physical/Chemical Properties *
Solubility in Water:NEGLIGIBLE
Appearance and Odor:SAND - GRANULAR, CRUSHED OR GROUND LIKE FLOUR; NO
ODOR OR TASTE.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
DISSOLVED BY HYDROFLUORIC ACID WHICH CAN RESULT IN SILICON
TETRAFLUORIDE (SIF*4) WHICH IS CORROSIVE GAS.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE IN SANITARY LANDFILL I/A/W STATE, LOCAL
& FEDERAL REGULATIONS ON SOLID WASTES.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR NIOSH APPRVD POS PRESS SUPPLIED AIR RESP
APPLICATION & UNTIL ALL VAPS & SPRAY MISTS ARE EXHSTED. INDIVIDUALS
W/HISTORY OF LUNG/BRT HG PROBS/PRIOR RXN TO ISOCYANATE(SUPDAT)
Ventilation:PROVIDE SUFFICIENT VENTILATION IN VOLUME & PATTERN TO KEEP
CONTAMINANTS BELOW APPLICABLE OSHA REQUIREMENTS.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . COVERALLS ARE RECOMMENDED.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING & BEFORE EATING
OR SMOKING.
Supplemental Safety and Health
2-5% DETERGENT, BALANCE WATER. PRESS CAN BE GENERATED. DO NOT SEAL
NOT USE/BE EXPOS TO PROD. DO NOT PERMIT ANYONE (ING 8)
* Product Identification *
Preparer's Name:T.R. LOUER
CAGE:0ERJ7
CAGE:0ERJ7
* Composition/Information on Ingredients *
Ingred Name:ISOCYANIC ACID, HEXAMETHYLENE ESTER, POLYMERS (HDI);
(ALIPHATIC POLYISOCYANATE RESIN)
Other REC Limits:0.5 MG/M3, S (MFR)
OSHA PEL:N/K
ACGIH TLV:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SOLVENT NAPHTHA (PETROLEUM), LIGHT AROMATIC; (AROMATIC
HYDROCARBON-A)
Ingred Name:ACETIC ACID, BUTYL ESTER; (N-BUTYL ACETATE) (CERCLA). VP:8
Ingred Name:VOLATILE ORGANIC COMPOUNDS: 4.6%.
Ingred Name:SUPP DATA:W/OUT PROTECTION IN PAINTING AREA. FOLLOW
RESPIRATOR MANUFACTURER'S DIRECTIONS FOR RESPIRATOR USE.
Ingred Name:EFTS OF OVEREXP:RPTD OVEREXP TO MAY CAUSE LUNG INJURY, INCL
Ingred Name:ING 9:CAUSE ASTHMA-LIKE RXNS W/SHORTNESS OF BREATH,
AMOUNTS.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INGEST:GI DISTRESS. INHAL:MAY CAUSE
NOSE & THROAT IRRIT. RPTD & PRLNG OVEREXP TO SOLVS MAY LEAD TO PERM
BRAIN & NERV SYS DMG. EYE WATERING, HDCHS, NAUS, DIZZ & LOSS OF
COORD ARE SIGNS THAT SOLV LEVELS ARE TOO HIGH. EXPOS TO
ISOCYANATES MAYCAUSE RESP SENSIT. THIS EFT MAY BE PERM. INDIVIDUALS
W/BRTHG (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:PROBS/PRIOR RXN TO ISOCYANATES MUST
NOT BE EXPOS TO VAPS/SPRAY MIST OF THIS PROD. EYE CONT:MAY CAUSE
IRRIT/BURNING. SKIN CONT:RPTD/PRLNG LIQ CONT MAY CAUSE IRRIT
W/DISCOMFORT & DERM. ING 1:RP TD EXPOS MAY CAUSE ALLERGIC SKIN
RASH, ITCH, SWELL. MAY CAUSE EYE IRRIT W/DISCOMFORT,
TEARING/BLURRED VISION. (ING 9)
Medical Cond Aggravated by Exposure:INDIVIDUALS W/PRE-EXISTING LUNG
DISEASE, ASTHMA OR BREATHING DIFFICULTIES MAY HAVE INCREASED
SUSCEPTIBILITY TO THE TOXICITY OF EXCESSIVE EXPOSURES.
* First Aid Measures *
First Aid:INGEST:CALL MD IMMEDIATELY & HAVE NAMES OF INGREDIENTS
AVAILABLE. INHAL:REMOVE TO FRESH AIR IF BREATHING DIFFICULTY
PERSISTS, OR OCCURS LATER, CONSULT MD. EYES:IMMEDIATELY FLUSH
SKIN:WASHW/SOAP & WATER. IF IRRITATION OCCURS, CONTACT MD.
* Fire Fighting Measures *
Flash Point Method:CC
Lower Limits:0.8%
Extinguishing Media:WATER SPRAY, FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . WATER FROM FOG NOZZLES MAY BE USED TO COOL CLOSED
CONTAINERS TO PREVENT PRESSURE BUILD UP.
Unusual Fire/Explosion Hazard:WHEN HEATED ABOVE FLASH POINT, EMITS
FLAMM VAPS WHICH, WHEN MIXED W/AIR, CAN BURN/BE EXPLO. FINE
MISTS/SPRAYS MAY BE FLAMM AT TEMPS BELOW FLASH POINT.
* Accidental Release Measures *
Spill Release Procedures:DO NOT BREATHE VAPS. DO NOT GET IN EYES/ON
SKIN. WASH NIOSH APPRVD POS PRESS SUPPLIED AIR VAP/PARTICULATE
IGNIT. ABSORB W/INERT MATL. VENT AREA. POUR LIQ DECONTAM SOLN OVER
SPILL &(SUPDAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:OSHA STORAGE:IC. DO NOT BREATHE VAPORS
OR MISTS. OBSERVE LABEL PRECAUTIONS. KEEP AWAY FROM HEAT, SPARKS &
FLAME. CLOSE CONTAINER AFTER EACH USE.
Other Precautions:FLAMMABLE LIQUID. GROUND CONTAINERS WHEN POURING. DO
COATING W/OUT NIOSH APPROVED RESPIRATOR OR APPROPRIATE VENTILATION.
* Physical/Chemical Properties *
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Evaporation Rate & Reference:LESS THAN ETHER
Solubility in Water:MISCIBLE
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
WATER, AMINES, METAL SALTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CO, CO*2, SMOKE.
* Disposal Considerations *
Waste Disposal Methods:DO NOT ALLOW MATERIAL TO CONTAMINATE GROUND
WATER SYSTEMS. INCINERATE ABSORBED MATERIAL I/A/W FEDERAL, STATE &
LOCAL REQUIREMENTS. DO NOT INCINERATE IN CLOSED CONTAINERS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH APPROVED RESPIRATOR.
Ventilation:MECHANICAL EXHAUST REQUIRED.
Other Protective Equipment:ANSI APPROVED EMERGENCY EYEWASH AND DELUGE
SHOWER .
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
WASTE DISPOSAL METHOD: UNLESS SPECIFIED DIFFERENTLY, NON-CONTAMINATED
PACKAGING MAY BE TREATED LIKE HOUSEHOLD WASTE OR RECYCLED. DISPOSE
OF IN ACCORDANCE WITH LOCAL, STATE, AND FEDERAL REGULATIONS (FP
N).
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:AQUEOUS SOLUTION (CONTAINING INGREDIENTS 2 TO 4)
Other REC Limits:N/K
OSHA PEL:N/K
OSHA STEL:N/K
ACGIH TLV:N/K
ACGIH STEL:N/K
Fraction by Wt: ING NAME
Other REC Limits:N/K
OSHA PEL:N/K
OSHA STEL:N/K
ACGIH TLV:N/K
ACGIH STEL:N/K
Ingred Name:3-MORPHOLINOPROPANESULFONIC ACID;
(3-MORPHOLINOPROPANSULFONIC ACID)
Code:F
Other REC Limits:N/K
OSHA PEL:N/K
OSHA STEL:N/K
ACGIH TLV:N/K
ACGIH STEL:N/K
Ingred Name:ISOPROPANOL
Other REC Limits:N/K
OSHA STEL:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION: MAY BE HARMFUL BY
INHALATION. MATERIAL IS IRRITATING TO MUCOUS MEMBRANES AND UPPER
RESPIRATORY TRACT. EYES: CAUSES SEVERE EYE IRRITATION. SKIN: CAUSES
SKIN IRRITATION. MAY BE HARMFU L BY SKIN ABSORPTION. PROLONGED OR
REPEATED EXPOSURE TO SKIN CAUSES DEFATTING AND DERMATITIS.
INGESTION: MAY BE HARMFUL IF SWALLOWED. PROLONGED EXPOSURE: CAN
CAUSE NAUSEA, HEADACHE, AND VOMITING NARCO TIC EFFECT. CAN CAUSE
CENTRAL NERVOUS SYSTEM DEPRESSION. CHRONIC EFFECTS: TARGET ORGANS:
NERVES, KIDNEYS. THE PRODUCT SHOULD BE HANDLED WITH THE NORMAL
CAUTION ACCORDED CHEMICALS. ADDITIONAL HARMFUL P ROPERTIES CANNOT
BE RULED OUT.
Effects of Overexposure:SEE HEALTH HAZARDS.
* First Aid Measures *
First Aid:EYES: IMMEDIATELY FLUSH WITH COPIOUS AMOUNTS OF WATER FOR AT
SEPARATING THE EYELIDS WITH FINGERS. SKIN: IMMEDIATELY WASH WITH
SOAP AND COPIOU S AMOUNTS OF WATER. INHALATION: REMOVE TO FRESH
AIR. IF NOT BREATHING, GIVE ARTIFICIAL RESPIRATION. IF BREATHING IS
DIFFICULT, GIVE OXYGEN. INGESTION: WASH OUT MOUTH WITH WATER
PROVIDED PERSON IS CONS CIOUS. CALL A PHYSICIAN. REMOVE AND WASH
CONTAMINATED CLOTHING PROMPTLY.
* Fire Fighting Measures *
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL POWDER, OR APPROPRIATE
FOAM.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . USE WATER SPRAY TO COOL FIRE-EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:VAPOR MAY TRAVEL CONSIDERABLE DISTANCE TO
SOURCE OF IGNITION AND FLASH BACK. CONTAINER EXPLOSION MAY OCCUR
UNDER FIRE CONDITIONS.
* Accidental Release Measures *
Spill Release Procedures:SHUT OFF ALL SOURCES OF IGNITION. EVACUATE
AREA. WEAR NIOSH APPROVED SELF-CONTAINED BREATHING APPARATUS,
ABSORB ON SAND OR VERMICULITE A ND PLACE IN CLOSED CONTAINERS FOR
DISPOSAL. USE NON-SPARKING TOOLS. VENTILATE AREA AND WASH SPILL
SITE AFTER MATERIAL PICKUP IS COMPLETE.
*Handling and Storage *
Handling and Storage Precautions:KEEP TIGHTLY CLOSED. STORE TIGHTLY
SPARKS, AND OPEN FLAME.
Other Precautions:DO NOT GET IN EYES, ON SKIN, OR ON CLOTHING. DO NOT
BREATHE VAPOR. SEVERE EYE IRRITANT.
* Physical/Chemical Properties *
Appearance and Odor:COLORLESS LIQUID; CHARACTERISTIC ODOR.
* Stability and Reactivity Data *
OXIDIZING AGENTS, ACIDS, ACID ANHYDRIDES, HALOGENS, AND ALUMINUM.
Hazardous Decomposition Products:TOXIC FUMES OF CARBON MONOXIDE AND
CARBON DIOXIDE.
* Toxicological Information*
CHEMICAL SUBSTANCES (RT ECS) DATA IS PRESENTED HERE. SEE ACTUAL
ENTRY IN RTECS FOR COMPLETE INFORMATION.
* Ecological Information *
Ecological:NOT APPLICABLE.
* Disposal Considerations *
Waste Disposal Methods:THERE ARE NO UNIFORM REGS FOR DISP OF
CHEMS/RESIDUES. CHEM RESIDUES GEN COUNT AS SPECIAL WASTE. MFR
RECOMMENDS THAY YOU CONT EITHER AUTHS IN CHARGE/APPRVD WASTE DISP
COMPANIES WHICH WILL ADVISE YOU ONHOW TO DISPOSE OF SPECIAL
WASTE. HANDLE CONTAM PACKAGING IN SAME WAY AS SUBSTANCE ITSELF.
(SUP DAT)
* MSDS Transport Information *
Transport Information:NOT APPLICABLE.
* Regulatory Information *
JORDAN, KOREA, NEW ZEALAND, SINGAPORE, VIETNAM: CHECK ACGIH TLV.
NEGATIVE: CELL TRANSFORM. (STATE REGS)
State Regulatory Information:N/K --SARA REGS: SA7/SHE; N
* Other Information *
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE ADEQUATE VENTILATION. A NIOSH APPROVED
RESPIRATOR APPROPRIATE FOR THE EXPOSURE OF CONCERN .
Ventilation:USE ADEQUATE VENTILATION.
Other Protective Equipment:MAKE EYE BATH AND EMERGENCY SHOWER (MEETING
ANSI DESIGN CRITERIA - ) AVAILABLE. SKIN PROTECTION: SUFFICIENT
TO PROTECT SKIN.
Supplemental Safety and Health
* Product Identification *
Product ID:SULFITE TEST KIT
Preparer's Name:A. SEYMOUR
* Composition/Information on Ingredients *
Ingred Name:POTASSIUM IODIDE
ACGIH TLV:NOT AVAILABLE
Ingred Name:SODIUM BICARBONATE
Fraction by Wt: 2% G
ACGIH TLV:NOT AVAILABLE
Ingred Name:POTASSIUM IODATE
Fraction by Wt: 1.8% G
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PRIMARY ROUTES OF ENTRY: SKIN CONTACT.
EYE CONTACT. INHALATION AND INGESTION. EFFECTS OF ACUTE EXPOSURE:
IRRITANT. EYES: CAUSES IRRITATION. SKIN: CAUSES SKIN IRRITATION.
INHALATION: MAY CAUSE RESPIRA TORY TRACT INFLAMMATION. INGESTION:
CAUSES GASTROINTESTINAL IRRITATION. EFFECTS OF CHRONIC
OVEREXPOSURE: TO THE BEST OF MANUFACTURER'S KNOWLEDGE THE CHRONIC
TOXICITY OF THIS SUBSTANCE HAS NOT BEEN FUL LY INVESTIGATED.
TERATOGEN: N/P. MUTAGEN: N/P. REPRODUCTIVE TOXIN: N/P.
SYNERGISTIC PRODUCTS: N/P.NOT FULLY INVESTIGATED: (X).
* First Aid Measures *
First Aid:EYES: WASH EYES AND SKIN WITH COPIOUS QUANTITIES OF WATER FOR
AND WATER. REMOVE CONTAMINATED CLOTHING. IF IRRITATION OCCURS OR
PERSISTS , CALL A PHYSICIAN. INHALATION: REMOVE PATIENT TO FRESH
AIR. ADMINISTER APPROVED OXYGEN SUPPLY IF BREATHING IS DIFFICULT.
CALL A PHYSICIAN. INGESTION: KEEP PATIENT WARM AND QUIET. GIVE A
LARGE QUANTIT Y OF WATER TO DILUTE. INDUCE VOMITING. CALL A
PHYSICIAN.
* Fire Fighting Measures *
Flash Point:NONE.
Autoignition Temp:Autoignition Temp Text:N/AP
Lower Limits:NOT APPLIC
Upper Limits:NOT APPLIC
Extinguishing Media:USE EXTINGUISHING MEDIA APPROPRIATE TO SURROUNDING
FIRE CONDITIONS.
Fire Fighting Procedures:SELF CONTAINED BREATHING APPARATUS (NIOSH
APPROVED - ) WITH A FULL FACEPIECE OPERATED IN A PRESSURE DEMAND OR
OTHER POSITIVE PRESSURE MODE.
Unusual Fire/Explosion Hazard:POTASSIUM IODATE IS AN OXIDIZING MATERIAL
WHICH CONTRIBUTES TO COMBUSTION OF OTHER MATERIALS. HAZARDOUS
COMBUSTION PRODUCTS: OXIDES OF POTASSIUM AND IODINE, IODIDES.
SENSITIVE TO IMPACT: NO. SEN SITIVE TO STATIC DISCHARGE: NO.
* Accidental Release Measures *
Spill Release Procedures:AVOID RAISING DUST. SWEEP UP AND PLACE IN
CONTAINER FOR DISPOSAL.
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL, DRY AREA, IN
ACCORDANCE WITH GOOD STORAGE AND HANDLING PRACTICES.
Other Precautions:NONE.
* Physical/Chemical Properties *
HCC:T6
Vapor Density:NOT APPLIC
Solubility in Water:SOLUBLE.
Appearance and Odor:SEPARATE VIALS OF EA COMPONENT:WHITE POWDERS. NO
ODOR SPECIFIED BY MFR .
Percent Volatiles by Volume:NOT APPLIC
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
REDUCING AGENTS. STRONG ACIDS. STRONG BASES.
Hazardous Decomposition Products:REACTION PRODUCT(S): NOT AVAILABLE.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH APPLICABLE FEDERAL,
STATE AND LOCAL REGULATIONS .
* MSDS Transport Information *
Transport Information:DOT HAZARD CLASSIFICATION: NOT REGULATED. PIN
(UN#/NA#): NOT APPLICABLE.
* Regulatory Information *
Federal Regulatory Information:WHMIS CLASS: NOT AVAILABLE.
* Other Information *
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:SELF CONTAINED NIOSH APPROVED RESPIRATOR IF TLV
IS REACHED.
Ventilation:LOCAL EXHAUST AS NEEDED TO REMAIN BELOW PEL.
Other Protective Equipment:BARRIER CREAM, EYE BATH & SAFETY SHOWER.
Supplemental Safety and Health
* Product Identification *
Preparer's Name:THOMAS E. MAREK
* Composition/Information on Ingredients *
Ingred Name:MINERAL SPIRITS (VAPOR PRESSURE 2.0 MM HG)
Other REC Limits:NONE SPECIFIED
Other REC Limits:N/KE SPECIFIED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES- CAN CAUSE SEVERE IRRITATION,
REDNESS, TEARING, BLURRED VISION. SKIN- PROLONGED OR REPEATED
CONTACT CAN CAUSE MODERATE IRRITATION, DEFATTING, DERMATITIS.
BREATHING- EXCESSIVE INHALATION OF VAPORS CAN CAUSE NASAL AND
RESPIRATORY IRRITATION, DIZZINESS, WEAKNESS, FATIGUE, NAUSEA,
HEADACHE, POSSIBLE UNCONSCIOUSNESS
Effects of Overexposure:AND EVEN ASPHYXIATION. SWALLOWING- CAN CAUSE
GASTROINTESTINAL IRRITATION, NAUSEA, VOMITING AND DIARRHEA.
ASPIRATION INTO LUNGS CAN CAUSE CHEMICAL PNEUMONITIS WHICH CAN BE
FATAL.
* First Aid Measures *
First Aid:SKIN-WASH EXPOSED AREA W/SOAP & WATER. REMOVE CONTAM CLOTH &
LAUNDER BEFORE REUSE. EYES-FLUSH W/LG AMTS WATER, LIFTING UPPER &
LOWER LIDS OCCASIONALLY, GET MEDICAL ATTENTION. INGESTION- DO NOT
INDUCE VOMITING. KEEP PERSON WARM & GET MEDICAL ATTENTION.
INHALATION- REMOVE TO FRESH AIR. IF BREATHING IS DIFFICULT, GIVE
OXYGEN. IF BREATHING HAS STOPPED, GIVE CPR. KEEP PERSON WARM, QUIET
& GET MED AID.
* Fire Fighting Measures *
Flash Point Method:SCC
Lower Limits:1.0
Upper Limits:6.0
Extinguishing Media:FOAM, DRY CHEMICAL, CARBON DIOXIDE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS WITH A
FULL FACEPIECE OPERATED IN PRESSURE-DEMAND OR OTHER POSITIVE
PRESSURE MODE WHEN FIGHTING FIRES.
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR & MAY TRAVEL
ALONG GROUND OR BE MOVED BY VENTILATION & IGNITE BY IGNITE SOURCES
AT LOCATIONS DISTANT FROM MATERIAL HANDLING POINT.
* Accidental Release Measures *
Spill Release Procedures:ABSORB LIQUID ON PAPER, VERMICULITE, FLOOR
ABSORBENT OR OTHER ABSORBENT MATERIAL AND PICK UP WITH SHOVEL.
*Handling and Storage *
Handling and Storage Precautions:AVOID PROLONGED OR REPEATED SKIN
CONTACT. KEEP AWAY FROM HEAT, SPARKS, OPEN FLAMES. USE WITH
ADEQUATE VENTILATION.
* Physical/Chemical Properties *
HCC:F4
Vapor Density:> AIR
Evaporation Rate & Reference:<1.0
Solubility in Water:NONE
Appearance and Odor:LIQUID, MILD SOLVENT ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:EXCESSIVE HEAT, SPARKS, OPEN FLAME.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY YIELD CARBON
DIOXIDE AND/OR CARBON MONOXIDE.
* Disposal Considerations *
Waste Disposal Methods:INCINERATE UNDER SAFE CONDITION. DISPOSE OF IN
ACCORDANCE WITH LOCAL, STATE AND FEDERAL REGULATION.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH APPRVD ORGANIC VAPOR CARTRIDGE OR SCBA
WHEN EXPOSURE LIKELY.
Ventilation:USE LOCAL EXHAUST TO MAINTAIN EXPOSURE BELOW TLV/PEL.
Other Protective Equipment:WEAR RUBBER APRON.
Supplemental Safety and Health
* Product Identification *
Product ID:BELITE M8;ANTIFOAM AGENT
Preparer's Name:BRUCE SCHWEMMER
CAGE:CIBAG
CAGE:CIBAG
* Composition/Information on Ingredients *
Ingred Name:ISOPROPYL ALCOHOL (SARA III)
Fraction by Wt: <9.0%
Ingred Name:POLYETHYLENE-POLYETHYLENE GLYCOLS
Ingred Name:POLYETHYLENE GLYCOL
Ingred Name:PROPYLENE GLYCOL,MONO(OLEIC ACID)ESTER
Ingred Name:WATER
Fraction by Wt: <3.0%
Ingred Name:ETHYLENE OXIDE (SARA III)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Explanation of Carcinogenicity:ETHYLENE OXIDE IS REQUIRED TO BE LISTED
Effects of Overexposure:EYES/NOSE/THROAT:EXPOSURE TO HI-CONC OF
ISOPROPYL ALCH, MAY CAUSE IRRITAT.,DROWINESS,HEADACHE, ETC.
Medical Cond Aggravated by Exposure:SKIN & RESPIRATORY PROBLEMS MAY BE
AGGRAVATED.
* First Aid Measures *
REMOVE CONTAMINATED CLOTHING & LAUNDER BEFORE REUSE. INHALED:REMOVE
FROM EXPOSURE. INGESTED:GIVE LARGE QUANTITY OF WATER. GET MEDICAL
ATTENTIO N.
* Fire Fighting Measures *
Flash Point Method:COC
Upper Limits:2.0(ALCOHOL)
Extinguishing Media:CARBON DIOXIDE,DRY CHEM,ALCOHOL FOAM;WATER MAYBE
INEFFECTVE
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:DECOMPOSITION & COMBUSTION PRODUCTS MAYBE
TOXIC.ISOPROPYL ALCH IS AN OSHA CLASS IB FLAM LIQ.
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALLIGNITION SOURCES. PROVIDE ADEQUATE
VENTILATION. ABSORB ONTO SAND OR SIMILIAR NON-COMBUSTIBLE MATERIAL.
SHOVEL WITH NON-SPARKING TOOLS INTO CLOSEABLE CONTAINER FOR
DISPOSAL. WEAR PROTECTV. EQ UIPM. STATED; DONOT FLUSH TO SEWER, OR
WATER BODY.
Neutralizing Agent:NONE
*Handling and Storage *
Handling and Storage Precautions:KEEP AWAY FROM HEAT,SPARKS,FLAMES.
GROUND CONTAINERS. USE NON-SPARKING TOOLS. STORE TIGHTLY CLOSED IN
A COOL,WELL VENTILATED AREA.
Other Precautions:DO NOT CUT,WELD,ETC. EMPTY DRUMS.
* Physical/Chemical Properties *
HCC:F3
Vapor Density:2.1
Evaporation Rate & Reference:(BUAC =1), 2.7
Solubility in Water:COMPLETE
Appearance and Odor:PALE STRAW-COLORED LIQUID; SIMILIAR TO RUBBING ALC
Percent Volatiles by Volume:9%
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING OR REDUCING AGENTS
Stability Condition to Avoid:HIGH TEMPERATURES, SPARKS, AND OPEN FLAMES
Hazardous Decomposition Products:NORMAL PRODUCTS OF COMBUSTION.
Conditions to Avoid Polymerization:WILL NOT POLYMERIZE
* Disposal Considerations *
Waste Disposal Methods:DISPOSE-IAW FEDERAL,STATE & LOCAL REGULATIONS;
INCINERATION RECOMMENDED.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:MASK W/ORGANIC VAPOR CARTRIDGE IS RECOMMENDED.
USE POSITIVE PRESSURE AIR-SUPPLIED ON SCBA IN THE EVENT OF A LARGE
SPILL.
Ventilation:LOC EXHAUST:INDOORS USE LAB HOOD.OUTDOORS WORK UPWIND.MECH
(GEN) RECOMMENDED FOR USE IN ENCLOSED/SEMIENCLOSED WORK AREA.
Other Protective Equipment:EMPLOYEE MUST WEAR APPROPRIATE IMPERVIOUS
CLOTHING & EQPMT TO PREVENT REPEATED/PROLONGED SKIN CONTACT W/THIS
SUBSTANCE.
Work Hygienic Practices:WASH HANDS AFTER HANDLING & PRIOR TO
EAT/SMOKE/DRINK.LAUNDER CONTAMIN CLOTHING PRIOR TO REUSE.DO NOT
SMOKE IN WORK AREA.
Supplemental Safety and Health
W/DRAW IMMED IN CASE OF RISING SOUND FROM VENTING SAFETY DEVICE OR ANY
DISCOLORATION OF STORAGE TANK DUE TO FIRE(SUBJECT TO FIRE CHIEF'S
DIRECTIONS). 1STAID EYE:FLUSH IMMED W/COPIOUS AMTS OF WATER LIF
* Product Identification *
Product ID:NO.2 FUEL OIL
* Composition/Information on Ingredients *
Ingred Name:NO.2 FUEL OIL(COMPLEX MIXTURE OF
AS BENZENE SOLUBLES.)
Other REC Limits:NONE RECOMMENDED
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:MIST/VAPOR MAY CAUSE RESP TRACT
IRRIT, CNS DEPRESS. INGEST:IRRIT, CNS DEPRESS, COMA, DEATH.
SKIN:DERM,DIRECT CONTACT MAY CAUSE EXTREME IRRIT W/SEVERE ERYTHEMS
& EDEME W/BLISTERING & OPEN SORES.EYE:IRRIT IS POSSIBLE BUT
ANIMAL STUDIES INDICATE IT UNLIKELY.CHRONIC:RENAL
FAILURE,DEGENERATIVE CHANGES OF LIVER/KIDNEY
Explanation of Carcinogenicity:NONE OF THE INGREDIENTS ARE LISTED AS
CARCINOGENS BY IARC, NTP, OR OSHA. AMES TESTS DID NOT INDICATE
MUTAGENIC ACTIVITY.
Effects of
Overexposure:INHAL:GIDDINESS,HEAD,DIZZ,NAU,VOMIT,INCOORDINATION,NAR
COSIS,STUPOR,COMA,UNCONSC,WT LOSS,ANEMIA,WEAKNESS,NERVOUSNESS,RENAL
FAILURE,PAINS IN LIMBS,PERIPHERAL NUMBNESS,PARESTHESIAS.
INGEST:IRRIT GIDDINES S,VERTIGO,HEADACHE,ANESTHETIC STUPOR,CNS
DEPRESS,COMA,DEATH. SKIN:DRYING,CRACKING,DERM,NARCOSIS,RASH OF
PIMPLES & SPOTS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MFG.
* First Aid Measures *
First Aid:INHAL:REMOVE TO FRESH AIR.STOP BREATH GIVE ARTIF RESP.KEEP
WARM/REST. INGEST:DO NOT INDUCE VOMIT.IF INGEST>1MG/KG REMOVE BY
GASTRIC LAVAGE BY QUALIF MED PERSONNEL.IF VOMIT KEEP HEAD LOWER
FLEET'S PHOSPHO-SODA DILUTED 1:4 W/WATER. SKIN:REMOVE CONTAMIN
CLOTH.WIPE OFF EXCESS W/DRY CLOTH.WASH W/SOAP OR MILD DETERGENT &
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:0.6
Upper Limits:7.5
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL, FOR LARGER
FIRES USE WATER SPRAY, FOG OR FOAM.
Fire Fighting Procedures:USE SUPPLIED-AIR BREATHING EQPMT FOR ENCLOSED
AREAS.COOL EXPOSED CONTAINERS W/WATER SPRAY.CONTINUE WATER SPRAY
TIL ENTIRE CONTAINER CONTENTS ARE COOL.(SEE SUPP)
Unusual Fire/Explosion Hazard:DO NOT MIX/STORE W/STRONG OXIDANTS NOR
STORE/POUR NEAR IGN SOURCES.DO NOT PRESS/CUT/HEAT/WELD/EXPOSE EMTPY
CNTNRS TO IGN SOURCES.VAP HEAVY & TRAVEL & FLASHBACK.
* Accidental Release Measures *
Spill Release Procedures:SUT OFF IGN SOURCES.ISOLATE HAZ AREA &
RESTRICK ENTRYL.SM:TAKE UP W/SAND/OTHER ABSORBENT MATL.PLACE INTO
CONTNRS.LG:DIKE FAR AHEAS TO PREVENT ENTRANCE INTO WATER COURSES
&/OR GROUND WATER.OBSERVE LOC/ STATE/FED GOVRT SPILL & WATER
QUALITY REGS.
Neutralizing Agent:NONE SPECIFIED BY MFG.
*Handling and Storage *
Handling and Storage Precautions:AVOID EXCESSIVE INHALATION OR SKIN
CONTACT. ISOLATE FROM SOURCES OF IGNITION.
Other Precautions:NONE SPECIFIED BY MFG.
* Physical/Chemical Properties *
HCC:F4
Vapor Density:>5
Spec Gravity:0.9
Solubility in Water:INSOLUBLE.
Appearance and Odor:BROWN, SLIGHTLY VISCOUS LIQUID.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
MAY REACT WHEN EXPOSED TO OXIDIZING MATERIALS.
Stability Condition to Avoid:MAY BE IGNITED BY HEAT/SPARKS/FLAME.VAP
MAY TRAVEL TO IGNITION SOURCES & FLASHBACK.VAP EXPLO HAZ
INDOORS/OUTDOORS/SEWERS
Hazardous Decomposition Products:THERM DECOMP MAY RELEASE VARIOUS
ACIDS, & ALDEHYDES.
* Disposal Considerations *
Waste Disposal Methods:UNDER EPA RCRA IF PRODUCT BECOMES A WASTE MATL
STATE REGS REGARDI NG PROPER DISPOSAL.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF USE CNDTNS GEN VAPS/MISTS, WEAR NIOSH/MSHA
APPRVD RESP APPROP FOR THOSE EMISSION LEVS. APPROP RESPS MAY BE
FULL FACEPIECE OR HALF MASK PURIFYING CARTRIDGE RESP EQUIP FOR ORG
VAPS/MISTS, A NIOSH/MSH A APPRVD SCBA IN PRESS DEMAND (SUPDAT)
Ventilation:LOCAL EXHAUST IS CAPABLE OF MAINTAINING EMISSIONS AT POINT
OF USE BELOW PEL.
Other Protective Equipment:LONG SLEEVED SHIRT,TROUSERS, RUBBER BOOTS,
SHOWER
Work Hygienic Practices:CONTACT LENSES SHOULD NOT BE WORN WHEN WORKING
W/CHEMS BECAUSE CONTACT LENSES MAY CONTRIBUTE TO SEVERITY OF EYE
INJURY.
Supplemental Safety and Health
OTHER PREC: AFTER HNDLG. DO NOT GET IN EYES, ON SKIN/ON CLTHG. RESP
PROT: MODE, OR NIOSH/MSHA APPRVD SUPPLIED AIR RESP. SPILL PROC:
EVENT, ALWAYS WEAR EYE PROT. EXTING ALL IGNIT SOURCES & ENSURE THAT
ALL HNDLG EQUIP IS ELEC GROUNDED. FOR SML SPILLS/DRIPS, MOP/WIPE
UP & DISP OF IN DOT-APPRVD WASTE CNTNRS. FOR (ING 2)
* Product Identification *
Product ID:CHLORINATING GRANULES
CAGE:WATMI
CAGE:WATMI
* Composition/Information on Ingredients *
Ingred Name:S-TRIAZINE-2,4,6 (1H, 3H, 5H,)-TRIONE, DICHLORO-, SODIUM
SALT; (SODIUM DICHLOROISOCYANURATE)
Ingred Name:SUPP DATA: LRG SPILLS, CONTAIN BY DIKING W/SOIL/OTHER
NON-COMBUST ABSORB MATLS & THEN PUMP INTO DOT APPRVD WASTE (ING 3)
Ingred Name:ING 2: CNTNRS;OR ABSORB W/NON-COMBUST SORBENT MATL, PLACE
RESIDUE IN DOT APPRVD WASTE CNTNRS. KEEP OUT OF SEWERS,(ING 4)
Ingred Name:ING 3: STORM DRAINS, SURF WATERS, & SOILS. COMPLY W/ALL
APPLIC GOVT REGS ON SPILL REPORTING, & HNDLG & DISP OF WASTE.
* Hazards Identification *
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION OF DUST CAN CAUSE
IRRITATION OR BURNS TO NOSE, THROAT AND MUCOUS MEMBRANES.
RESPIRABLE SIZE DUST REACHING LUNGS IS EXTREMELY TOXIC AND CAN BE
FATAL;HOWEVER, PHYSICAL NATURE OF PRODUCT IS SU CH THAT DUST
PARTICLES OF RESPIRABLE SIZES ARE NOT LIKELY TO BE ENCOUNTERED.
PRODUCT IS VERY CORROSIVE (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HEALTH HAZARDS: TO EYES. CONTACT OF DUST WITH
EYES CAN CAUSE SEVERE IRRITATION AND EVEN BLINDNESS. CONTACT WITH
SKIN MAY CAUSE SEVERE IRRITATION, BURNS, OR TISSUE DESTRUCTION. IF
SWALLOWED, CAUSES SEV ERE BURNS TO DIGESTIVE TRACT AND CAN BEFATAL.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INHAL: REMOVE TO FRESH AIR. GIVE ARTF RESP IF NOT BRTHG. GET
IMMED MED ATTN. EYE: FLUSH IMMED W/LOTS OF RUNNING WATER FOR AT
IMMEDIA TE MEDICAL ATTENTION. SKIN: IMMED FLUSHW/LOT OF RUNNING
REUSE. GET IMMED MED ATTN. INGEST: DO NOT INDUCE VOMIT. GET IMMED
MED ATTN.
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:WATER ONLY.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:THERMAL DECOMPOSITION PRODUCTS ARE TOXIC
AND IF ALLOWED TO CONCENTRATE MAY BE EXPLOSIVE.
* Accidental Release Measures *
RUBB APRON, & NIOSH/MSHA APPRVD SCBA IN PRESS DEMAND MODE/SUPP-AIR
RESP. IF SPILL/LEAK IS SML, A NIOSH/MSHA APPRVD FULL FACEPIECE AIR
PURIFYING CARTRIDGE RESP EQUIP FOR ORG VAPS MAY BE NEC.IN ANY
(SUPDAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS AND
FLAMES. STORE IN COOL, DRY, WELL VENTILATED PLACE AWAY FROM
INCOMPATIBLE MATERIALS.
Other Precautions:VENT CNTNR FREQUENTLY,& MORE OFTEN IN WARM WEATHER,
TO RELEIVE PRESS. ELECTRONICALLY GROUND ALL EQUIP WHEN HNDLG PROD &
USE ONLY NON-SPARKING TOOLS. KEEP CNTNR TIGHTLY CLSD WHEN NOT IN
USE.DO NOT USE PRESS TO EMPTY CNTNR.WASH THORO (SUPDAT)
* Physical/Chemical Properties *
Solubility in Water:COMPLETE
Appearance and Odor:WHITE GRANULAR; CHLORINE ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:NO
MOISTURE, ORGANIC MATTER, INORGANIC REDUCING AGENTS, SOLVENTS, AMMONIA
OR NITROGEN COMPOUNDS.
Stability Condition to Avoid:MOISTURE.
Hazardous Decomposition Products:CHLORINE GAS.
* Disposal Considerations *
Waste Disposal Methods:DISP OF CONTAMD PROD & MATLS USED IN CLEANING UP
SPILLS/LEAKS IN MANNER APPRVD FOR MATL. CONSULT APPROP FED, ST,&
LOC REG AGENCIES TO ASCERTAIN PROPER DISP PROCS. NOTE: EMPTY CNTNRS
CAN HAVE RESIDUES,GASES & MISTS & ARE SUBJECT TO PROPER WASTE
DISP.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF ENGINEERING CONTROLS FAIL OR EMERGENCY
OCCURS; USE NIOSH/MSHA APPROVED RESPIRATOR OR SUPPLIED AIR
Ventilation:SUFFICIENT VENTILATION IN VOLUME & PATTERN SHOULD BE
PROVIDED TO KEEP EXPOSURE BELOW OSHA PEL.
Other Protective Equipment:CLOTHING AS NEEDED TO PREVENT SKIN CONTACT.
Work Hygienic Practices:WASH HANDS BEFORE EATING, SMOKING, OR USING
RESTROOM. REMOVE & LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health
MSDS ENTERED BY DLA-HMIS UNDER PROJECT FOR GSA.
* Product Identification *
Preparer's Name:MIKE LICHATOWICH
* Composition/Information on Ingredients *
Ingred Name:HIGH SOLIDS SILICON
Other REC Limits:NONE RECOMMENDED
Ingred Name:MINERAL SPIRITS [STODDARD SOLVENT]
Other REC Limits:NONE RECOMMENDED
Ingred Name:VM & P NAPHTHA
Fraction by Wt: 6%
Other REC Limits:NONE RECOMMENDED
Ingred Name:ZINC OXIDE
Fraction by Wt: 3%
Other REC Limits:NONE RECOMMENDED
Ingred Name:COBALT (SARA III),DUST AND FUME
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.1 MG/M3
Ingred Name:PROPRIETARY INGREDIENTS
Fraction by Wt: BALANCE
Other REC Limits:NONE RECOMMENDED
Ingred Name:VOLATILE ORGANIC COMPOUND: 2.8 LB/GAL
Other REC Limits:NONE RECOMMENDED
Ingred Name:BLACK PIGMENT
Fraction by Wt: < 1%
Other REC Limits:NONE SPECIFIED
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION MAY CAUSE NASAL &
RESPIRATORY IRRITATION, CS DEPRESSION. CONTACT MAY CAUSE SKIN & EYE
IRITATION. INGESTION MAY CAUSE GASTROINTESTINAL IRRITATION.
CHRONIC: NONE. TARGET ORGANS:Explanation of Carcinogenicity:NO
INGREDIENTS OF A CONCENTRATION OF 0.1% OR GREATER IS LISTED AS A
CARCINOGEN OR SUSPECTED CARCINOGEN.
Effects of Overexposure:INHALED: DIZZINESS, DROWSINESS, HEADACHE,
NAUSEA, VOMITING, WEAKNESS, FATIGUE, CONFUSION, SHORTNESS OF
BREATH. EYES: LACRIMATION, REDNESS, BLURRED VISION. SKIN: REDNESS,
DEFATTING, ITCHING, DISCOMFORT . INGESTED: ABDOMINAL PAIN, NAUSEA,
VOMITING, DIARRHEA.
Medical Cond Aggravated by Exposure:NONE KNOWN.
* First Aid Measures *
First Aid:INHALED-REMOVE TO FRESH AIR. IF BREATHING STOPPED, GIVE
ARTIFICIAL RESPIRATION. GET MEDICAL ATTENTION IMMEDIATELY.
MINUTES, LIFT LIDS. GET I MMEDIDATE MEDICAL ATTENTION.
SWALLOWING-DO NOT INDUCE VOMITING! IF CONSCIOUS, GIVE 1-2 GLASSES
OF WATER. CALL DOCTOR OR POISON CONTROL CENTER IMMEDIATELY. TREAT
SYPMTOMATICALLY.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:0.8
Extinguishing Media:DRY CHEMICAL, FOAM, CARBON DIOXIDE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS WITH
FULL-FACEPIECE & FULL PROTECTIVE CLOTHING.WATER MAY BE USED TO COOL
CLOSED CONTAINERS TO PREVENT RUPTURE/EXPLOSION.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. DURING EMERGENCY CONDITIONS, OVEREXPOSURE
TO DECOMPOSITION PRODUCTS MAY CAUSE A HEALTH HAZARD.
* Accidental Release Measures *
Spill Release Procedures:ELIMINATE ALL SOURCES OF IGNITION.MINIMIZE THE
BREATHING OF VAPORS & AVOID SKIN CONTACT.ABSORB WITH INERT MATERIAL
SUCH AS CLAY,SOIL,OR A COMMERCIALLY AVAILABLE ABSORBENT.SHOVEL
RECLAIMED LIQUID & ABS ORBENT INTO RECOVERY OR SALVAGE DRUM FOR
DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:AVOID STORAGE IN HIGH TEMPERATURE
AREAS OR NEAR FIRE OR OPEN FLAME. KEEP CONTAINERS CLOSED WHEN NOT
IN USE. AVOID ROUGH HANDLING.
Other Precautions:CONTAINERS OF THIS MATERIAL MAY BE HAZARDOUS WHEN
EMPTY. DO NOT WELD OR FLAME CUT EMPTY DRUMS. CONTACT LENSES SHOULD
NOT BE WORN WHEN WORKING WITH THIS MATERIAL.
* Physical/Chemical Properties *
HCC:F4
Vapor Density:>1
Evaporation Rate & Reference:<1 (ETHER=1)
Solubility in Water:SLIGHT
Appearance and Odor:LIQUID; SOLVENT ODOR
Corrosion Rate:MIMIMAL
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:THIS MATERIAL HAS BEEN FOUND TO BE STABLE
UNDER REASONABLE CONDITIONS OF STORAGE AND USE.
Hazardous Decomposition Products:CAN PRODUCE CARBON MONOXIDE AND CARBON
DIOXIDE.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
HAZARD CATAGORIES-IMMEDIATE (ACUTE) HEALTH AND FIRE HAZARDS.
CHEMICALS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE NIOSH/MSHA APPRVD RESPS AS SPECIFIED BY
INDUS HYGIENIST/QUALIFIED SFTY PROF. LUNG FUNC TESTS ARE RECOM FOR
USERS OF NEG PRESS DEVICES. USE NIOSH/MSHA APPRVD FUME RESP/AIR
Ventilation:LOCAL EXHAUST VENTILATION SHOULD BE USED TO CONTROL
EXPOSURE TO AIRBORNE DUST & FUME WHENEVER POSSIBLE.
Other Protective Equipment:PROTECTIVE CLTHG SUCH AS UNIFORMS, DISP
COVERALLS, SAFETY SHOES, ETC.
Work Hygienic Practices:CONTACT LENSES SHOULD NOT BE WORN IF WORKING W/
METAL DUSTS & POWDERS.
Supplemental Safety and Health
EXTING MEDIA:CLASS "D" EXTING PWDR. EFTS OF OVEREXP:SYMPS RANGING FROM
SHORTNESS OF BREATH & COUGH TO PERM DISABILITY DUE TO LOSS OF LUNG
FUNC, FIBROSIS/SUBSEQUENT EFTS ON HEART MAY BE CAUSED BY EXCES S
EXPOS TO DUST/FUMES. CNS DEPRESS HAS BEEN IDENTIFIED W/EXCESS
MANGANESE EXPOS. NICKEL & CHROMIUM METAL & (ING 8)
* Product Identification *
Preparer's Name:SAFETY DEPARTMENT
* Composition/Information on Ingredients *
Ingred Name:SILICON
Fraction by Wt: 0.1% MAX
Ingred Name:SUPDAT:CERTAIN CMPDS HAVE BEEN LINKED TO NASAL, BRONCH &
LUNG CANCERS. ALUM & IRON HAVE BEEN INDICATED TO CAUSE (ING 9)
Ingred Name:ING 8:GI DISORDERS & NON-SIGNIFICANT CHANGES IN LUNG.
Ingred Name:MED CNDTNS:ASTHMA, EMPHYSEMA, CHRONIC BRONCH, ETC MAY INCUR
CONDUCTED ON INDIVIDUALS WHO MAY BE EXPOSED TO FURTHER RISK (ING
EXPOSURE.
IRRIT PERSISTS GET MD.
Ingred Name:SPILL PROC:AVOID CONTAM OF AIR & H*2O. PROPERLY LBL ALL
EXISTS IT IS ADVISABLE TO DEVEL EMER SPILL RESPONSE PLAN.
Ingred Name:RESP PROT:BELOW OSHA LIMITS FOR AIR CONTAMINATION.
Ingred Name:EYE PROT:W/TINTED LENS .
Ingred Name:COBALT (SARA III)
Fraction by Wt: 1.0% MAX
OSHA PEL:0.1 MG/M3;AS CO
Ingred Name:CHROMIUM (SARA III)
Fraction by Wt: 1.0% MAX
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:IRON (III) OXIDE; (IRON)
Fraction by Wt: 2.0% MAX
Ingred Name:MANGANESE (SARA III)
Fraction by Wt: 1.0% MAX
OSHA PEL:(C) 5 MG/M3 DUST
Ingred Name:MOLYBDENUM
Ingred Name:NICKEL (SARA III)
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:UNDER NORM HNDLG & USE OF SOLID FORM
OF MATLS THERE ARE FEW HLTH HAZS. CUTTING, WELDING, MELTING,
GRINDING, ETC OF MATLS WILL PRDCE DUST, FUME/PARTICULATE WHICH MAY
PRESENT SIGNIFICANT HLTH HAZS. ACUT E:METAL DUST & FUMES OF
ELEMENTS IN INGSECT CAN CAUSE IRRIT TO SKIN, EYE & MUC MEMBS. CONT
MAY CAUSE (EFTS OF OVEREXP)
Explanation of Carcinogenicity:COBALT:GROUP 2B(IARC).
NICKEL:ANTICIPATED TO BE A CARCINOGEN(NTP); GROUP 2B(IARC).
Effects of Overexposure:HLTH HAZ:ALLERGIC SKIN RXNS. DUST, PWDRS/ FUME,
EXPOS WHICH ABRADES SKIN CAN CAUSE IRRIT & DERM. INJURY TO EYES IS
GEN RSLT OF PARTICULATE IRRIT/MECH INJURY TO CORNEA/CONJ BY DUST/
PARTICULATE. EXCESS INHAL CAN CAUSE RESP IRRIT, COUGH, BRONCH,
CHILLS, "FUME FEVER" & ASTHMA-LIKE SYMPS. CHRONIC:RESP DISEASE
W/(SUPDAT)
Medical Cond Aggravated by Exposure:INDIVIDUALS WHO MAY HAVE HAD
ALLERGIC RXN/ SENSITIVITY TO METALS IN ING SECT MAY ENCOUNTER SKIN
RASH/DERM IF SKIN CONT W/PROD OCCURS. PERS W/IMPAIRED PULM FUNC,
* First Aid Measures *
First Aid:INHAL:BRTHG DFCLTY REQS REMOVAL TO FRESH AIR. IF BRTHG HAS
STOPPED, PERFORM ARTF RESP & GET MD @ ONCE. INGEST:HAVE AFFECTED
PERS SWALLOW LG QTYS OF H2O & ATTEMPT TO INDUCE VOMIT IF CONSCIOUS.
GET MD @ ONCE. SKIN:CUTS & ABRASIONS CAN BE TREATED BY STD FIRST
AID. CONTAM W/DUST/PWDR CAN BE REMOVED BY WASHING W/SOAP & H2O. IF
IRRIT PERSISTS GET MD. EYES:DUST/PWDR SHLD BE FLUSHED W/COPIOUS
* Fire Fighting Measures *
Flash Point:NONE
Lower Limits:NONE
Upper Limits:NONE
Extinguishing Media:NONCOMBUST. USE EXTING MEDIA APPROP TO SURROUND
FIRE. TO EXTING METAL PWDR FIRE USE DRY SAND, DRY
GRAPHITE/OTHER(SUPDAT)
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . IF MATLS ARE REDUCED TO POWDER FORM, CAUTION
MUST BE USED TO PREVENT FIRE/EXPLOSION.
Unusual Fire/Explosion Hazard:NO UNUSUAL FIRE OR EXPLOSION HAZARDS ARE
ASSOCIATED W/MATERIALS.
* Accidental Release Measures *
Spill Release Procedures:IN SOLID FORM THESE MATLS POSE NO SPECIAL
CLEAN-UP PROBS. IF MATLS ARE IN PWDR/DUST FORM, CLEAN-UP SHLD BE
CONDUCTED W/VACUUM SYS UTILIZING HIGH EFFICIENCY PARTICULATE AIR
FILTRATION SYS. CAUT SHLD BE TAKEN TO MIN AIRBORNE GEN OF
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:PRODS MUST BE HANDLED ACCORDING TO
SIZE, SHAPE & QTY OF MATLS INVOLVED. SOLID METAL MAY REQ USE OF
HOISTS, CRANES, ETC.
Other Precautions:PWDRS SHLD BE MOVED/TRANSPORTED TO MIN SPILL/RELS
POTNTL. IN SOLID FORM MATLS POSE NO SPEC PROBS. STORE METAL/METAL
PWDR IN DRY AREA. DO NOT STORE ADJACENT TO MINERAL ACIDS. FINE
METAL PWDR SHLD BE KE PT AWAY FROM FLAMES & SOURCES OF IGNIT.
* Physical/Chemical Properties *
HCC:N1
Solubility in Water:NONE
Appearance and Odor:SOLID; SILVER GRAY COLOR; NO ODOR.
Percent Volatiles by Volume:NONE
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
AVOID CONT W/MINERAL ACIDS & OXIDIZING AGENTS WHICH MAY GEN HYDROGEN
GAS; EVOLUTION OF HYDROGEN MAY BE EXPLO HAZ.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:VARIOUS ELEMENTAL METALS & METAL
OXIDES MAY BE GEN FROM WELDING, CUTTING, GRINDING, MELTING OR DROSS
HNDLG OPERATIONS.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF WASTE MATERIAL I/A/W LOCAL, STATE OR
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WHEN ENGINEERING CONTROLS ARE NOT FEASIBLE OR
SUFFICIENT TO ACHIEVE FULL CONFORMANCE WITH ACCEPTABLE EXPOSURE
LIMITS (INGREDIENT SECTION), USE NIOSH APPROVED RESPIRATORY
PROTECTION EQUIPMENT. RESPIRAT ORS SHOULD BE SELECTED BASED ON THE
Ventilation:ENGINEERING CTLS SHOULD BE USED WHENEVER FEASIBLE TO
MAINTAIN CONCS BELOW ACCEPTABLE EXPOS LIMS INCL, BUT NOT LIMITED
TO, ENCLOSURES, LOC VENT & DILUTION VENT.
FACESHIELD .
Other Protective Equipment:ANSI APPROVED EYE WASH AND DELUGE SHOWER .
WEAR HEAT PROTECTIVE CLOTHING IF THERE IS A POTENTIAL FOR CONTACT
WITH HEATED MATERIAL.
Supplemental Safety and Health
FIRST AID PROC: REMOVAL MAY LEAD TO MORE DMG OF SKIN & UNDERLYING TISS.
IF REMOVALINDICATED (EG, SOLIDIFIED MATL IS LOCATED ON CRITICAL
PART OF HAND/FACE), REMOVAL W/MINERAL OIL RECOM. DUE TO EXTREM ELY
HIGH TEMP OF MOLTEN POLYMER AT TIME OF CNTCT, BACTERIAL INFECTION
UNDER SOLIDIFIED MATL IS UNLIKELY TO BE PRESENT.
* Product Identification *
* Composition/Information on Ingredients *
MG/KG
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EMERGENCY OVERVIEW: APPROXIMATELY 1/8
- 3/8" CLEAR TO TRANSLUCENT SOLID PLASTIC PELLETS W/SLIGHT ESTER
ODOR. DOES NOT CONTAIN MATERIALS WHICH MAY CONTRIBUTE TO IMMEDIATE
HEALTH, PHYSICAL OR ENVIRONMEN TAL HAZARDS. POTENTIAL HEALTH
EFFECTS OF THIS POLYMER: IN SOLID FORM, THIS POLYMER IS NOT
CONSIDERED TO BE A HEATLH HAZARD, ALTHOUGH THE PELLETS AND THE
DUSTS GENERATED FROM THEM MAY BE MILDLY IRRITAT ING TO THE SKIN AND
EYES BY MECHANICAL ACTION. IF SWALLOWED, POLYMER MAY POSE POSSIBLE
INTESTINAL OBSTRUCTION. DUST CREATED DURING HANDLING OR PROCESSING
MAY BE MILDLY IRRITATING TO THE RESPIRATORY SY STEM. (EFFECTS OF
OVEREXPOSURE)
Effects of Overexposure:HEALTH HAZARDS: WHEN HEATED, THIS POLYMER MAY
RELEASE FUMES AND/OR VAPORS THAT ARE IRRITATING TO THE EYES, NOSE,
THROAT AND SKIN. OVEREXPOSURE TO FUMES OR VAPORS MAY ALSO CAUSE
HEADACHE, NAUSEA, SHORT NESS OF BREATH AND COUGH. MOLTEN OR HEATED
MATERIAL CAN CAUSE SERIOUS BURNS TO UNPROTECTED SKIN AND EYES.
Medical Cond Aggravated by Exposure:THERE ARE NO KNOWN MED CNDTNS
AGGRAVATED BY EXPOS TO PROD. HOWEVER, CERTAIN SENSITIVE INDIVIDUALS
& INDIVIDUALS W/RESP IMPAIRMENTS MAY BE AFFECTED BY EXPOS TO
COMPONENTS IN THE PROCESSING EMISSIONS.
* First Aid Measures *
First Aid:INGEST: IF PROD INGESTED, CONTACT MD OR POISON CONTROL CENTER
AS APPROP WHENEVER ANY FOREIGN OBJECT IS SWALLOWED. SKIN: IF
CONTACTED BY MOLTEN POLYMER, COOL IMMED W/COLD OR ICE WATER. DO NOT
ATTEMPT R EMOVAL OF ANY SOLIDIFIED MATL. GET MED ATTN PROMPTLY.
EYES: IF CONTACT BY MOLTEN POLYMER, IMMED FLUSH EYES W/PLENTY OF
GET MED ATTN IM MED. INHAL: IMMED REMOVE VICTIM TO FRESH AIR. IF
VICTIM HAS STOPPED BRTHG GIVE ARTF RESP, PREFERABLY MOUTH-TO-MOUTH.
GET MED ATTN IMMED. NOTE TO MD: IN CASE OF MOST BURNS, ALLOW
SOLIDIFIED MATL TO SLO UGH OFF ON ITS OWN. ATTEMPTED (SUPDAT)
* Fire Fighting Measures *
Flash Point:DOES NOT APPLY
Extinguishing Media:USE WATER SPRAY, DRY CHEMICAL, FOAM OR CARBON
DIOXIDE.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . IF POSSIBLE, WATER SHOULD BE APPLIED AS A SPRAY FROM A
FOGGING NOZZLE SINCE THIS POLYMER IS SURFACE BURNING MATERIAL.
(NOTE: INDIVIDUALS S HOULD PERFORM ONLY THOSE FIRE-FIGHTING
PROCEDURES FOR WHICH THEY HAVE BEEN TRAINED.)
Unusual Fire/Explosion Hazard:KNOWN OR ANTICIPATED PRODUCTS OF
COMBUSTION: CARBON MONOXIDE IS THE PRIMARY HAZARDOUS COMBUSTION
PRODUCT (SEE ALSO STABILITY AND REACTIVITY SECTION). NFPA RATING:
NO NFPA RATING AVAILABLE. HMIS RATING : HEALTH: 0; FLAMMABILITY: 0;
REACTIVITY: 0.
* Accidental Release Measures *
Spill Release Procedures:ENVIRONMENTAL PRECS: AVOID UNCONTROLLED
RELEASES OF MATL. WHERE SPILLS ARE POSS, COMPREHENSIVE SPILL RELS
RESPONSE PLAN SHOULD BE DEVELOPED & IMPLEMENTED. PLASTIC PELLETS
WATER DISCHARGE PERMIT. ACCIDENTAL RELS PROCS: USE GOOD
HOUSEKEEPING PRACTICES SINCE (TOXICOLOGICAL INFO)
*Handling and Storage *
Handling and Storage Precautions:STORE IN DRY PLACE AWAY FROM MOISTURE,
EXCESSIVE HEAT AND SOURCES OF IGNITION.
Other Precautions:HANDLING OF PELLETS IN BOTH LOADING & UNLOADING
OPERATIONS AS WELL AS FABRICATION MAY CAUSE DUST TO BE FORMED &
NECESSARY PRECS FOR PERSONAL PROTECTION (SEE EXPOSURE CONTROLS,
PERSONAL PROTECTION) SHO ULD BE USED. WHEN TRANSFERRING PELLETS,
PRECS SUCH AS GROUNDING & BONDING CAN PREVENT BUILD-UP OF ST ATIC
ELECTRICITY.
* Physical/Chemical Properties *
Boiling Pt:B.P. Text:DOES NOT APPLY
Vapor Pres:DOES NOT APPLY
Solubility in Water:INSOLUBLE
Appearance and Odor:APPROX 1/8-3/8" CLEAR TO TRANSLUCENT SOLID PLASTIC
PELLETS W/SLIGHT ESTER ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NITRIC AND SULFURIC ACIDS, HALOGENS, HYDROGEN PEROXIDE AND
CHLORINATING AGENTS.
Stability Condition to Avoid:GENERALLY STABLE BLOW OR WITHIN
RECOMMENDED PROCESSING CONDITIONS.
Hazardous Decomposition Products:UNDER CERTAIN CNDTNS, THERMAL DECOMP
PRODS HAVE BEEN REPORTED. THEY MAY INCL, BUT ARE NOT LIMITED TO,
CARBON, OXIDES OF CARBON, OXIDES OF NITROGEN, VINYL ACETATE, WATER,
ACROLEIN, (TRANSPORT INFO)
* Toxicological Information*
Toxicological Information:TOXICOLOGICAL INFO (FROM THE LITERATURE) FOR
PELLETS MAY BE SLIPPING HAZ. WEAR APPROP NIOSH APPRVD RESP PROT &
PROT CLTHG AS DESCRIBED IN EXPOSURE CONTROLS, PERSONAL PROTECTION.
CNTN SPILLED MATL. TRANSFER T O SECURE CNTNRS. IN EVENT OF
UNCONTROLLED RELEASE OF THIS MATL, USER SHOULD DETERMINE IF RELEASE
IS REPORTABLE UNDER APPLICABLE LAWS & REGS.
* Ecological Information *
Ecological:ENVIRONMENTAL FATE INFORMATION (FROM THE LITERATURE) FOR
THIS POLYMER: THIS MATERIAL IS GENERALLY INERT AND INSOLUBLE AND IS
NOT EXPECTED TO HAVE ANY ADVERSE EFFECT ON THE ENVIRONMENT. THIS
MATERIAL M AY DETERIORATE BY A NUMBER OF MECHANISMS INCLUDING
PHOTO- AND THERMO-OXIDATIVE DEGRADATION. PHOTODEGRADED POLYMERS ARE
ALSO MORE EASILY BIODEGRADED. ECOTOXICITY DATA (FROM THE
LITERATURE) FOR THIS POL YMER: NO DATA AVAILABLE ON THIS PRODUCT.
HOWEVER, BIRDS, FISH AND OTHER WILDLIFE MAY EAT PELLETS WHICH MAY
OBSTRUCT THEIR INTESTINAL TRACTS.
* Disposal Considerations *
Waste Disposal Methods:ALL RECOVERED MATL SHOULD BE PACKAGED, LABELED,
TRANSPORTED & DISPOSED OF OR RECLAIMED IN CONFORMANCE W/APPLIC FED,
STATE & LOCAL LAWS & REGS & IN CONFORMANCE W/GOOD ENGINEERING
PRACS. RECLAIM WHERE P OSS. INFO PROVIDED IN MSDS APPLIES ONLY TO
PROD AS MANUFACTURED BY EQUISTAR CHEMS, LP. PROCESSING, U SE &
CONTAM MAY MAKE THIS INFO (TRANSPORT INFO)
* MSDS Transport Information *
Transport Information:DEPARTMENT OF TRANSPORTATION (DOT): NOT REGULATED
BY DOT AS A HAZ MATL. WASTE DISP METH: INAPPROP FOR MATL
REQUIRING DISP. STATE & LOCAL LAWS & REGS MAY DIFFER FROM FED REQS
& REQS MAY CHANGE OR BE RE-INTERPRETED. IT IS RESPONSIBILITY OF
WASTE GENERATOR TO CHARACTERIZE WASTE STREAMS RELATIVE TO PERTINENT
REGULATORY PROVISIONS (INCL RCRA "CHARACTERISTIC" WASTE DEFINITIONS
HAZ DECOM PRODS: FORMALDEHYDE, OTHER ALDEHYDES, KETONES, ALCOHOLS,
ACETIC ACID, FATTY ACIDS, METHANE, ETHANE, ACETYLENE, OTHER ORGANIC
VAPS & FUMES (SEE ALSO FIRE FIGHT MEASURES).
* Regulatory Information *
CATEGORIES: THIS PROD DOES NOT MEET CRITERIA OF ANY HAZ CATEGORIES.
ABOVE THRESHOLD LEVELS. STA TE REG INFO: THESE CHEMS CONSIDERED
TO BE IMPURITIES OR CONTAMINANTS.OTHER INFO: 5 MG/M3 FOR
RESPIRABLE DUST. TLV/TWA (ACGIH THRESHOLD LIM VALUE/TIME-WEIGHTED
AVERAGE): NO ACGIH TLV FOR THIS MIX. FOR PARTICULATES NOT
RESPIRABLE DUST. ADDITIVES (IF ANY PRESENT) IN PROD ARE
ENCAPSULATED IN THERMOPLASTIC RESIN W/LIMITED RELS UNDER NORM (FED
REG INFO)
Federal Regulatory Information:TOX SUBSTANCE CTL ACT (TSCA): PROD IS
(OR IF MIX, COMPONENTS OF PROD ARE) LISTED IN TSCA INVENTORY OF
CHEM SUBSTANCES. NOTE: REG INFO PRESENTED HERE SHOULD NOT
NECESSARILY BE CONSIDERED AS ALL-INCLUSI VE. OTHER LOC, STATE, FED
& INTERNATL REGS MAY ALSO APPLY. SARA REG INFO: CNDTNS OF USE,
TRANSPORT & STOR. INCREASED RELS MAY OCCUR WHEN RESIN (OR MATL/PROD
MANUFACTURED FROM IT) IS SUBJECT TO GRIND ING, POLISHING, EXCESS
HEAT OR OTHER PROCESSES WHICH ENHANCE POTNTL FOR GENERATION OF
PARTICULATES, FUMES &/OR VAPS. SPECIFIC POTNTL FOR RELS UNDER
USER'S CNDTNS OF HNDLG THIS MATL SHOULD BE EVALUATED BY QUALIFIED
HLTH SPECIALIST.
WHICH ARE LISTED UNDER THIS STATE LAW. HOWEVER, MAY BE
NATURALLY-OCCURRING CONTAMINANTS OR UNINTENTIONALLY-INTRODUCED
IMPURITIES THAT APPEAR IN RAW MATLS OR MFG PROCESS USED TO PRDCE
PROD. WHILE MFR DOES NOT ROUTINELY ANALYZE THEIR PRODS OR SUPPLIER
RAW MATLS FOR SUCH IMPURITIES & CONTAMINANTS, POSSIBILITY OF THEIR
PRESENCE IN TRACE QTYS EXISTS. TO COMPLY W/CA LAW, MFR PROVIDES
FOLLOWING STATEMENT: WARNING: PROD CNTNS (OR MAY CNTN) TRACE AMTS
OF CHEM (O R CHEMS) KNOWN TO STATE OF CA TO CAUSE CANCER, BIRTH
DEFECTS &/OR OTHER REPRO HARM. IF PRESENT (SARA REG INFO)
* Other Information *
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE REQUIRED
Ventilation:LOCAL EXHAUST/MECHANICAL: NORMAL
Other Protective Equipment:APRON TO PROTECT CLOTHING.
Supplemental Safety and Health
* Product Identification *
Product ID:ADHESIVE
* Composition/Information on Ingredients *
Ingred Name:POLYVINYL ACETATE
Ingred Name:POLYVINYL ALCOHOL
Fraction by Wt: 2.5%
* Hazards Identification *
Effects of Overexposure:FOOD PACKAGE INDUSTRY
* First Aid Measures *
First Aid:WASH OFF WITH WATER-NO EMERGENCY PROCEDURES REQUIRED.
* Fire Fighting Measures *
Flash Point:NONE
* Accidental Release Measures *
Spill Release Procedures:FLUSH DOWN DRAIN WITH WATER.
*Handling and Storage *
Other Precautions:NONE REQUIRED
* Physical/Chemical Properties *
Solubility in Water:MISCIBLE
Appearance and Odor:WHITE OR RED VISCOUS LIQUID
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
* Disposal Considerations *
Waste Disposal Methods:WIPE OR MOP - NORMAL DISPOSAL METHODS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NECESSARY WHEN PERMISSABLE EXPOSURE LIMITS MAY
BE EXCEEDED DURING CUTTING, GRINDING OR WELDING. USE NIOSH/MSHA
APPROVED AIR-SUPPLIED RESPIRATOR IN CONFINED SPACES. USE ONLY
Ventilation:USE LOC EXHAUST WHEN CUTTING, GRINDING/WELDING. MAINTAIN
EXPOS BELOW LIM IN INGRED SECT. CONFINED SPACES REQ (SUPDAT)
Other Protective Equipment:FLAME RETARDANT CLOTHING. SELECT WELDING
LENSE SHADE FROM AWS PUB F2.2.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
HAZ DECOMP PROD:FLUORIDES & COMPLEX METALLICS. GASES MAY INCLUDE CO,
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:CHROMIUM; (CR) (SARA III)
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:IRON (III) OXIDE; (FE)
Fraction by Wt: 7%
Ingred Name:MANGANESE; (MN) (SARA III)
Fraction by Wt: 3%
OSHA PEL:(C) 5 MG/M3 DUST
Ingred Name:NICKEL; (NI) (SARA III)
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3
Ingred Name:TITANIUM; (TI) PEL/TLV AS TITANIUM DIOXIDE
Fraction by Wt: 4%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:METALLIC TASTE, NAUS, TIGHTNESS
OF CHEST, FEVER, IRRIT OF EYES, NOSE, THROAT & SKIN; LOSS OF
CONSCIOUSNESS/DEATH DUE TO WELDING GASES/LACK OF O*2.
CHRONIC:ADVERSE EFTS MAY RESULT FROM LONG TIME EXPOS TO WELDING
FUMES, GASES/DUSTS. THESE EFTS MAY INCL SKIN SENSIT, NEUROLOGICAL
DMG, & RESP (EFTS OF OVEREXPOS)
Explanation of Carcinogenicity:CHROMIUM:KNOWN CARCINOGEN (NTP), GROUP 1
(IARC); NICKEL:ANTICIPATED TO BE A CARCINOGEN (NTP), GROUP 2B
(IARC).
Effects of Overexposure:HLTH HAZ:DISEASE SUCH AS BRONCHIAL ASTHMA, LUNG
FIBROSIS/PNEUM. NI & CR MUST BE CONSIDERED POSS CARCIN. RECENT
EPIDEMIOLOGICAL STUDIES OF WORKERS MELTING & WORKING ALLOYS
CONTAINING NI/CR HAVE FOUND N O INCREASE RISK OF CANCER.
NEVERTHELESS, EXPOS MUST BE MAINTAINED BELOW LEV SPECIFIED.
Medical Cond Aggravated by Exposure:AGGRAVATION OF PREEXISTING
RESPIRATORY OR ALLERGIC CONDITIONS MAY OCCUR IN SOME WORKERS.
* First Aid Measures *
First Aid:INGEST:CALL MD IMMEDIATELY . EYES:IMMEDIATELY FLUSH WITH
. SKIN:FLUSH WITH COPIOUS AMOUNTS OF WATER. CALL MD . INHA L:REMOVE
FROM EXPOSURE AND OBTAIN PROMPT MD ATTENTION. IF VICTIM IS
UNCONSCIOUS, ADMINISTER OXYGEN. IF NOT BREATHING, RESUSITATE
IMMEDIATELY.
* Fire Fighting Measures *
Flash Point:NONFLAMMABLE
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONFLAMMABLE; HOWEVER, WELDING ARCS AND
SPARKS CAN IGNITE FLAMMABLE LIQUIDS AND VAPORS AND COMBUSTIBLE
SOLIDS.
* Accidental Release Measures *
Spill Release Procedures:VACUUM RESIDUE FROM CUTTING, GRINDING OR
WELDING OPERATIONS INTO SUITABLE CONTAINERS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:MAINTAIN EXPOS <PEL/TLV. USE INDUSTRIAL HYGIENE AIR
MONITORING TO ENSURE USE OF MATL DOES NOT CREATE EXPOS WHICH EXCEED
OZONE & NO*X. CHLORINATED SOLVENTS MAY BE DECOMPOSED BY ARC INTO
TOX GASES SUCH AS PHOSGENE. VENT:SPECIAL ATTENTION TO PROVISION OF
ADEQUATE VENTILATION.
* Physical/Chemical Properties *
Appearance and Odor:SOLID ALLOY WIRE.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:THE CONSITIUENTS OF FUME ARE GENERALLY
DIFFERENT FROM INGREDS, & MAY INCLUDE OXIDES OF METALS, CHROMATES,
(SUPDAT)
* Disposal Considerations *
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH EPA OR LOCAL
REGULATIONS. DISPOSAL MUST BE IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS .
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NOT APPLICABLE. USE NIOSH APPROVED RESPIRATOR
APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:NOT APPLICABLE.
Other Protective Equipment:NOT APPLICABLE. EMERGENCY EYEWASH AND DELUGE
SHOWER MEETING ANSI DESIGN CRITERIA .
Work Hygienic Practices:NOT APPLICABLE.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
Product ID:INSECT REPELLENT TOWELETTES
Preparer's Name:PHIL RIVES
CAGE:NRTHS
CAGE:NRTHS
* Composition/Information on Ingredients *
Ingred Name:M-TOLUAMIDE, N,N-DIETHYL-; (N,N-DIETHYL-META-TOLUAMIDE)
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:OTHER ISOMERS
Fraction by Wt: 4%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:INERT INGREDIENTS (TOWELETTE)
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: PERMANENT EYE DAMAGE, SKIN
IRRITATION, NASAL AND RESPIRATORY IRRITATION, STOMACH IRRITATION.
CHRONIC:
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:EYES: SEVERE IRRITATION. SKIN: IRRITATION,
REDNESS. INHALATION: NASAL AND RESPIRATORY IRRITATION. INGESTION:
NAUSEA, CRAMPS, VOMITING.
Medical Cond Aggravated by Exposure:DO NOT APPLY TO SUNBURNED, DAMAGED,
CUT OR WOUNDED/IRRITATED SKIN.
* First Aid Measures *
WITH SOAP AND WATER. INHALATION: REMOVE TO FRESH AIR. INGESTION: DO
NOT INDUCE VOMITING. GIVE WATER. GET MEDICAL ATTENTION FOR EYES AND
INGES TION.
* Fire Fighting Measures *
Extinguishing Media:FOAM, CARBON DIOXIDE OR DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . TREAT AS AN OIL FIRE.
Unusual Fire/Explosion Hazard:NONE.
* Accidental Release Measures *
Spill Release Procedures:NOT APPLICABLE FOR POUCHED PRODUCT WHICH IS
ABSORBED INTO TOWELETTE.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE. KEEP OUT
OF REACH OF YOUNG CHILDREN AND INFANTS. KEEP AWAY FROM HEAT AND
FLAME.
Other Precautions:DO NOT APPLY TO EYES, LIPS AND MOUTH AND DO NOT APPLY
TO THE HANDS OF YOUNG CHILDREN. AVOID CONTACT WITH PLASTICS, SUCH
AS EYEGLASS FRAMES, AND FABRICS SUCH AS ACETATE RAYON. DO NOT USE
UNDER CLOTHING .
* Physical/Chemical Properties *
Solubility in Water:INSOLUBLE
Appearance and Odor:CLEAR, COLORLESS LIQUID WITH MILD, AROMATIC ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
CONTACT WITH STRONG OXIDIZERS MAY PRODUCE AN EXPLOSIVE SITUATION.
Stability Condition to Avoid:WATER, HEAT OR ACIDIC OR ALKALINE
CONDITIONS MAY CAUSE THIS PRODUCT TO BREAK DOWN.
Hazardous Decomposition Products:UNKNOWN.
* Disposal Considerations *
Waste Disposal Methods:CONSULT CURRENT LOCAL, STATE AND FEDERAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF EXPOSURES EXCEED ESTABLISHED LIMITS, A
NIOSH/MSHA APPROVED RESPIRATOR FOR ASBESTOS SHOULD BE USED.
CONSULT YOUR SAFETY OFFICE/IH PERSONNEL FOR GUIDANCE FOR THE TASK
AT HAND.
Ventilation:LOCAL EXHAUST IS RECOMMENDED IN SITUATIONS WHERE DUST IS
GENERATED BY ABRASIVE ACTIONS, ABRASION OR OTHER MEANS.
Other Protective Equipment:AS REQUIRED FOR TASK AT HAND, AND THE
GUIDANCE SET FORTH BY YOUR SAFETY OFFICE OR IH PERSONNEL
Work Hygienic Practices:DONOT INHALE DUST CREATED BY ABRADING ACTIONS.
USE FULL PROTECTION AGAINST AIRBORNE FIBERS. AVOID AIRBORNE DUST
CREATION
Supplemental Safety and Health
GENERIC "MSDS" CREATED FOR "NSN" IDENTIFIED BY "DISC" AS CONTAINING
ASBESTOS.WHEN A MANUFACTURER'S SPECIFIC "MSDS" IS PROVIDED FOR
MATERIAL PROCURED UNDER THIS NSN, THIS GENERIC "MSDS" WILL BE
REMOVED.
* Product Identification *
Preparer's Name:DOD HMIS/DGSC-SSH
* Composition/Information on Ingredients *
Ingred Name:ASBESTOS, CHRYSOTILE
OSHA PEL:0.2 FIBERS/CC
Ingred Name:ASBESTOS & NATURAL/SYNTHETIC RUBBER COMPOSITION
Ingred Name:GENERIC "MSDS". SPECIFIC ASBESTOS TYPE NOT KNOWN. ONE
CITED IS ASSUMED. INFORMATION BASED ON SEGMENT "M" OF "DLSC TIR"
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: NO ACUTE EFFECTS ARE KNOWN;
CHRONIC: DUST FROM ABRASIVE ACTIONS(EG. CUTTING, MACHINING,
FILING, ETC.) MAYCONTAIN ASBESTOS FIBERS. CHRONIC OVEREXPOSURE
TO AIRBORNE FIBERS MAY LEAD TO ASBESTOSIS & MESOTHELIOMA.
SMOKINGCOMBINED W/FIBER INHALATION GREATLY INCREASES LUNG
CANCER RISK!
Explanation of Carcinogenicity:OVEREXPOSURE TO AIRBORNE CONCENTRATIONS
OF ASBESTOS MAY LEAD TO ASBESTOSIS AND MESOTHELIOMA.
Effects of Overexposure:INHAL: INHALATION OF AIRBORNE DUST CONTAINING
ASBESTOS FIBERS ON REPEATED EXPOSURE MAY CAUSE OR CAN LEAD TO
ASBESTOSIS/ MESOTHELIOMA; SKIN: N/K; EYE: POTENTIAL IRRITATION
FROM AIRBORNE DUST; INGEST: N/K.
Medical Cond Aggravated by Exposure:RESPIRATORY DEFICIENCIES DUE TO
REPEATED INHALATION OF AIRBORNE FIBERS.
* First Aid Measures *
First Aid:INHAL: REMOVE TO FRESH AIR. OBTAIN MEDICAL ADVICE; SKIN:
WASH EXPOSED AREA WITH SOAP & WATER; EYE: FLOOD W/ WATER. IF
IRRITATION OCCURS, GET MEDICAL ATTN; INGEST: CONSULT A
PHYSICIAN; OTHER: CHANGE CLOTHING AS REQUIRED TO AVOIDCARRYING
DUST PARTICLES INTO OTHER AREAS
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:MATERIAL IS NOT FLAMMABLE ; USE MEDIA APPROPRIATE
FOR SURROUNDING FIRE.
Fire Fighting Procedures:COMBUSTION PRODUCTS OF THIS MATERIAL MAY BE
TOXIC. USE A SELF-CONTAINED BREATHING APPARATUS WHEN FIGHTING FIRES
INVOLVING CHEMICAL PRODUCTS.
Unusual Fire/Explosion Hazard:NONE KNOWN
* Accidental Release Measures *
Spill Release Procedures:USE PROPER PERSONAL PROTECTION. VACUUM OR WET
CLEAN IF DUST IS INVOLVED. ANY VACUUM SYSTEM SHOULD BE EQUIPPED W/
AN OUTLET "HEPA" FILTER TO PREVENT REINTRODUCING ASBESTOS FIBERS TO
THE ATMOSPHERE.
*Handling and Storage *
Handling and Storage Precautions:HANDLE IN A MATTER TO MINIMIZE
FORMATION OR RETENTION OF AIRBORNE DUST. USE PROPER PERSONAL
PROTECTION FOR TASK AT HAND. CHECK W/YOUR SAFETY OFFICE!!!
Other Precautions:AS MANUFACTURED, LOCKED-IN ASBESTOS DOES NOT PRESENT
A HAZARD. ONLY WHEN THE ITEM IS SUBJECTED TO ABRASIVE ACTIONS &
DUST IS GENERATED, THEN ASBESTOS FIBERS MAY BE RELEASED & BECOME
AIRBORNE.
* Physical/Chemical Properties *
HCC:T6
Evaporation Rate & Reference:NONE
Solubility in Water:NOT SOLUBLE
Appearance and Odor:MANUFACTURED COMMODITY DESCRIBED BY LOGISTICS:
"ITEM-NAME"
Percent Volatiles by Volume:NONE
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:NONE KNOWN
* Disposal Considerations *
Waste Disposal Methods:DUST SHOULD BE HANDLED AS A HAZARDOUS AIR
LANDFILLS APPROVED FOR ASBESTOS DISPOSAL. NOTE IF ITEM UNDER
CONSIDERATION FOR DISPOSAL IS "FRIABLE OR NON-FRIABLE".
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:ORGANIC VAPOR (AIR PURIFYING OR FRESH AIR
SUPPLIED)
Ventilation:EXHAUST VENTILATION
* Product Identification *
Kit Part:Y
Preparer's Name:NORM GAUL
* Composition/Information on Ingredients *
Fraction by Wt: <1.0%
Other REC Limits:NONE RECOMMENDED
Fraction by Wt: 5.0%
Other REC Limits:NONE RECOMMENDED
Ingred Name:ANTI MAR AGENT
Fraction by Wt: <1.0%
Other REC Limits:NONE RECOMMENDED
Fraction by Wt: <1.0%
Other REC Limits:NONE RECOMMENDED
Fraction by Wt: <1.0%
Other REC Limits:NONE RECOMMENDED
Fraction by Wt: 5.0%
Fraction by Wt: <0.1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.1 MG/M3: STEL 0.1
Ingred Name:FLOW AGENT
Fraction by Wt: <1.0%
Other REC Limits:NONE RECOMMENDED
Fraction by Wt: <5.0%
Other REC Limits:*UNION CARBIDE)
Ingred Name:ANTI-FLOAT AGENT
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
Other REC Limits:NONE RECOMMENDED
Fraction by Wt: <5%
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL: IRRITAT OF RESPIRATORY TRACT.
NS DEPRESSION (HEADACHE/DIZZY/STAGGERING
GAIT/CONFUSION/UNCONSIOUS/COMA). SKIN:
IRRITAT/SWELLING/REDNESS/RASH. EYE:
IRRITAT/TEARING/REDNESS/SWELLING/STINGING. INGE ST:
IRRIAT/VOMIT/CHEMICAL PNEUMONITIS. CORROSIVE (MOUTH/STOMACH
TISSUE/DIGESTIVE TRACT).
Effects of Overexposure:CHRONIC: SKIN IRRITAT, DRYING, DEFATTING,CRACK,
SENSITIZATION. INHALE DIFFICULT BREATHING. ASTHMA OR OTHER ALLERGIC
REACTIONS.
Medical Cond Aggravated by Exposure:ASTHMA & OTHER RESPIRATORY
DISORDERS. SKIN ALLERGIES, ECZEMA & DERMITITS.
* First Aid Measures *
First Aid:INHAL: GET FRESH AIR. SYMPTOMS MAY BE DELAYED. GET MED AID.
SKIN: REMOVE CLOTHES. WASH W/SOAP & WATER. WASH CLOTHES BEFORE
INGEST: DO NT INDUCE VOMIT. GET MED AID.
* Fire Fighting Measures *
Flash Point Method:TCC
Extinguishing Media:FOAM, ALCOHOL-FOAM, CARBON DIOXIDE, DRY CHEMICAL,
WATER FOG, WATER SPRAY.
Fire Fighting Procedures:FULL EQUIPMENT W/SCBA, FULL PROTECTIVE
CLOTHING. USE WATER TO COOL CLOSED CONTAINERS TO PREVENT PRESSURE
BUILD-UP, AUTOIGNITION, EXPLOSION.
Unusual Fire/Explosion Hazard:KEEP CLOSED TIGHT. CLOSED CNTNR MAY
EXPLODE W/EXTREME HEAT. APPLICATION TO HOT SURFACES USE SPECIAL
PRECAUTIONS. POS HEALTH HAZ W/OVEREXPOSURE DECOMP PRODUCTS.
* Accidental Release Measures *
Spill Release Procedures:REMOVE ALL IGNITION SOURCES. VENTILATE AREA.
CONTAIN & REMOVE INERT ABSORBENT W/NON-SPARKING TOOLS.
*Handling and Storage *
AVOID HIGH TEMPERATURES, IGNITION SOURCES. STORE IN TIGHTLY CLOSED
CONTAINERS. VENTILATED AREAS.
Other Precautions:KEEP CONTAINERS TIGHT IN UPRIGHT, TO PREVENT LEAKAGE.
DONT HANDLE UNTIL MANUFACTURERS SAFTY PRECAUTIONS HAVE BEEN
UNDERSTOOD. SMOKE IN SMOKING AREAS ONLY.
Other Protective Equipment:*WITH SPLASH GUARDS, SIDE SHIELDS. USE LONG
SLEEVE & LEG CLOTHES.
Work Hygienic Practices:WASH HANDS BEFORE EATING, SMOKING, USING
BATHROOM.
Supplemental Safety and Health
NK
* Physical/Chemical Properties *
Vapor Density:>AIR
pH:NA
Viscosity:**
Evaporation Rate & Reference:0.4 (BUAC=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:GRAY LIQUID W/SOLVENT ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HIGH TEMPS, SPARKS, OPEN FLAMES.
Hazardous Decomposition Products:CABON MONOXIDE, CARBON DIOXIDE, OXIDES
OF NITROGEN.
* Disposal Considerations *
Waste Disposal Methods:IN ACCORDANCE W/FEDERAL, STATE & LOCAL
REGULATIONS. EMPTY CONTAINERS HAVE RESIDUE & FLAMMABLE VAPORS.
DONT INCINERATE CLOSED CONTAINERS.
* Other Information *
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR DUST MASK.
Ventilation:LOCAL EXHAUST: AS REQUIRED. MECHANICAL (GENERAL): VENT FAN.
Supplemental Safety and Health
SOLUBILITY IN WATER: POWDERS-APPRECIABLE. LIQUIDS-MISCIBLE.
* Product Identification *
Product ID:DEOXYRIBONUCLEIC ACID
* Composition/Information on Ingredients *
Ingred Name:DEOXRIBONUCLEIC ACID
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE SKIN, EYE/RESPIRATORY TRACT
IRRITATION UPON CONTACT. ALLERGIC REACTIONS IN CERTAIN SENSITIVE
INDIVIDUALS MAY DEVELOP.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, ALLERGIC REACTIONS.
Medical Cond Aggravated by Exposure:ALLERGIES, ASTHMA.
* First Aid Measures *
First Aid:INHALATION: REMOVE TO FRESH AIR. EYES/SKIN: WASH THOROUGHLY
W/WATER. OBTAIN MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
* Accidental Release Measures *
Spill Release Procedures:AVOID PHYSICAL CONTACT & DUST DURING REMOVAL.
USE NORMAL CLEAN-UP PROCEDURES & WASH THOROUGHLY W/WATER.
*Handling and Storage *
Handling and Storage Precautions:NONE
Other Precautions:NONE
* Physical/Chemical Properties *
Solubility in Water:(SEE SUPP)
Appearance and Odor:POWDERS- WHITE TO TAN. LIQUIDS-WHITE TO BROWN. BOTH
HAVE TYPICAL ENZYME ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
* Disposal Considerations *
Waste Disposal Methods:FLUSH IN SEWERAGE SYSTEM W/WATER IAW/FEDERAL,
STATE & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WHEN SPRAY APPLIED IN OUTDOOR/OPEN AREAS
W/UNRESTRICTED VENT & DURING SANDING & GRINDING OPERATIONS, USE
NIOSH/MSHA APPRVD MECH FILTER RESP TO REMOVE SOLID AIRBORNE
PARTICLES OF OVERSPRAY & SANDING DU ST. WHEN USED IN RESTRICTED
Ventilation:PROVIDE GEN DILUTION/LOC EXHST VENT IN VOL & PATTERN TO
Other Protective Equipment:NOT REQUIRED.
Work Hygienic Practices:REMOVE & WASH SOILED CLOTHING BEFORE REUSE.
WASH HANDS BEFORE EATING, SMOKING OR USING THE WASHROOM.
Supplemental Safety and Health
MFR'S TRADE NAME/PART NO:MASONRY COCOA COATING. FIRE FIGHT PROC:EXPOS
TO FIRE/EXTREME HEAT, WATER SHOULD BE USED TO COOL CLSD CNTNRS &
PVNT PRESS BUILD-UP/POSS AUTO-IGNIT. EXPLO HAZ:PRODS MAY CAUSE HL
TH HAZ. SYMPS MAY NOT BE IMMED APPARENT. OBTAIN MED ATTN. EXPLAN OF
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:VENT:STDS IN MIXING, APPLICATION & CURING AREAS, & TO
PRODUCT.
Ingred Name:WATER. VAP DENS:LTR/AIR.
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE). VAP DENS:HVR/AIR.
DENS:HVR/AIR. LEL:3.2%.
Fraction by Wt: <5%
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:PROPIONIC ACID, 2-METHYL-, MONOESTER
Fraction by Wt: <5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SILICA, CRYSTALLINE - CRISTOBALITE. VAP DENS:HVR/AIR.
Fraction by Wt: <5%
Ingred Name:SILICA, CRYSTALLINE - QUARTZ; (CRYSTALLINE SILICA). VAP
DENS:HVR/AIR.
ACGIH TLV:0.1 MG/M3 RDUST
Ingred Name:DIATOMACEOUS EARTH, FLUX CALCINED; (DIATOMACEOUS EARTH).
VAP DENS:HVR/AIR.
Fraction by Wt: <5%
Ingred Name:IRON (III) OXIDE; (IRON OXIDE). VAP DENS:HVR/AIR.
Fraction by Wt: <5%
ACGIH TLV:5 MG/M3 FUME (FE)
Ingred Name:IRON OXIDE, HDRATE; (TRANSPARENT YELLOW OXIDE). VAP
DENS:HVR/AIR.
Fraction by Wt: <5%
OSHA PEL:N/K
ACGIH TLV:N/K
Fraction by Wt: SEE ING
Ingred Name:RESP PROT:AREAS, WEAR NIOSH/MSHA APPRVD CHEM/MECH FILTERS
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL:IRRITATION OF RESPIRATORY
TRACT; HEADACHE, NAUSEA, DIZZINESS. EYE/SKIN CONT:MAY CAUSE
IRRITATION. INGEST:NO EFFECTS ANTICIPATED FROM INGESTION INCIDENTAL
TO NORMAL USE. LARGER QUANTITIES M AY CAUSE DISTRESS OF DIGESTIVE
TRACT & NAUSEA. CHRONIC:PROLONGED & REPEATED BREATHING OF SPRAY
MIST (EFTS OF OVEREXP)
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-CRISTOBALITE &
ANNUAL RPT (SUPDAT)
Effects of Overexposure:HLTH HAZ:&/OR SANDING DUST OVER A PERIOD OF
YEARS MAY CAUSE DUST DISEASE OF THE LUNGS. EXCESSIVE INHALATION OF
CRYSTALLINE SILICA IS ALSO KNOWN TO CAUSE SILICOSIS. (RISK DEPENDS
ON DURATION & LEVEL OF EXPOSURE).
Medical Cond Aggravated by Exposure:NONE WHEN USED I/A/W SAFE HANDLING
& USE INFORMATION.
* First Aid Measures *
First Aid:INHAL:REMOVE TO FRESH AIR. EYE:FLUSH W/LARGE AMOUNTS OF WATER
& WATER. REMOVE SOILED CLOTHING. INGEST:DRINK 1-2 GLASSES OF WATER
TODILUTE. DO NOT INDUCE VOMITING. CONSULTMD IMMEDIATELY. TREAT
SYMPTOMATICALLY. NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS
PERSON.
* Fire Fighting Measures *
Flash Point Method:SCC
Flash Point:NONE
Lower Limits:SEE INGS
Extinguishing Media:IN CASE OF FIRE, USE CO*2, DRY CHEMICAL, FOAM OR
OTHER NFPA APPROVED METHOD FOR TREATING A CLASS B FIRE.
Fire Fighting Procedures:USE NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP .
SUMMON PROFESSIONAL FIREFIGHTERS. WATER SPRAY MAY BE INEFT. IF
WATER IS USED, FOG NOZZ ARE PREF. IF(SUPDAT)
Unusual Fire/Explosion Hazard:DUE TO PRESS BUILD-UP, CLSD CNTNRS EXPOS
TO EXTREME HEAT MAY EXPLODE. AFTER WATER EVAPS, REMAINING MATL WILL
BURN. DURING EMER CNDTNS, OVEREXP TO DECOMP(SUPDAT)
* Accidental Release Measures *
Spill Release Procedures:WASH W/WATER. BEFORE ATTEMPTING CLEAN-UP,
REFER TO HAZARD CAUTION INFO IN OTHER SECTIONS OF THIS MSDS.
CONTAIN SPILLED MATERIAL & REMOVE W/INERT ABSORBENT. STORE IN
CLOSED CONTAINER UNTIL PROPERLY DIS POSED OF.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
CONTAINER CLOSED WHEN NOT IN USE. DO NOT REUSE EMPTY CONTAINERS.
KEEP OUT OF REACH OF CHILDREN.
Other Precautions:DO NOT BREATHE VAPORS, SPRAY MIST OR SANDING DUST.
USE ONLY W/ADEQUATE VENTILATION. DO NOT GET IN EYES.
* Physical/Chemical Properties *
Vapor Pres:SEE INGS
Vapor Density:SEE INGS
Spec Gravity:1.3
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT W/MATERIALS THAT ARE INCOMPATIBLE W/WATER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:MAY CAUSE HAZ FUMES WHEN HEATED TO
DECOMP. FUMES MAY CONTAIN CARBON MONOXIDE, CARBON DIOXIDE & OXIDES
OF METALS (INGS).
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF I/A/W LOCAL, STATE & FEDERAL
REGULATIONS. INCINERATE ONLY IN APPROVED FACILITY. DO NOT
INCINERATE CLOSED CONTAINERS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR NIOSH/MSHA APPRVD RESPS WHEN HNDLG &
APPLYING FIBER GLASS INSULATION PRODS I/A/W FOLLOWING NIOSH-BASED
Ventilation:PROVIDE GENERAL AND/OR LOCAL EXHAUST VENTILATION TO CONTROL
AIRBORNE DUST LEVELS BELOW EXPOSURE LIMITS.
Work Hygienic Practices:BATHE WITH SOAP & WARM WATER. WASH WORK CLOTHES
SEPARATELY & RINSE AFTER USE.
Supplemental Safety and Health
APPEAR/ODOR: KRAFT, ALUMINUM FOIL, VINYL/COMBINATION THEREOF. SOME
PRODS MAY HAVE COATING. YELLOW. FAINT RESIN ODOR. EXPLO HAZ: FACING
IN FIRE SITUATION MAY EMIT TOX FUMES & SMOKE CONTAINING CARBON DI
OXIDE, CARBON MONOXIDE & MOLECULAR FRAGMENTS OF HYDROCARB
PARTICULATES, CARBON-HYDROGEN-NITROGEN & NITROGEN- (ING 5)
* Product Identification *
Product ID:ULTRA DUCT
CAGE:CERTA
CAGE:CERTA
* Composition/Information on Ingredients *
Ingred Name:RESP PROT: WITH TYPE H FILTER (HEPA).
Ingred Name:UREA EXTENDED PHENOL-FORMALDEHYDE RESIN CURED; (UREA,
POLYMER WITH FORMALDEHYDE AND PHENOL (CURED))
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PARAFFIN; (CHLORINATED PARAFFINS)
Fraction by Wt: 7%
OSHA PEL:2 MG/M3 (FUME)
ACGIH TLV:2 MG/M3 (FUME)
Ingred Name:ACETIC ACID ETHENYL ESTER POLYMER WITH ETHENE
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPDAT: OXYGEN CMPDS. VINYL FACINGS MAY THERMALLY DECOMPOSE
Ingred Name:ING 5: JACKETING ON PIPE INSULATION WILL BEGIN TO THERMALLY
RELS HYDROGEN FLUORIDE. IN FIRE SITUATION, CARBON (ING 8)
Ingred Name:ING 7: MONOXIDE, CARBON DIOXIDE, HYDROGEN CHLORIDE,
HYDROGEN FLUORIDE & SULFUR DIOXIDE MAY ALSO BE FORMED.
Ingred Name:EFTS OF OVEREXP: IS OF LITTLE PRACTICAL SIGNIFICANCE." SM
Ingred Name:ING 9:STATISTICALLY SIGNIFICANT INCR IN LUNG CANCER DEATHS.
EXCESS IS RELATED TO ANY FACTORS IN WORK ENVIRON.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:EXPOS TO FIBER GLASS MAY CAUSE
TEMPORARY SKIN, EYE & UPPER RESP IRRIT. CHRONIC:IARC HAS REVIEWED
RESEARCH ON HLTH EFTS OF FIBER GLASS. IN STUDIES WHERE LAB ANIMALS
WERE FORCED TO INHALE FIBERS ( AT CONC > HUMAN EXPOS), NO EVID OF
CANCER/RESP DISEASE. IN OTHER EXPERIMENTS IN WHICH GLASS WOOL
FIBERS(EFTS OF OVEREXP)
Effects of Overexposure:HLTH HAZ:WERE ARTF INJECTED/SURGICALLY
IMPLANTED IN ANIMAL LUNGS, TUMORS WERE PRDCED. SUCH PROCS BYPASSED
VITREOUS WORKERS REVEALED SM STATISTICAL SIGNIFICANT EXCESS IN
MORTALITY (ING 9)
Medical Cond Aggravated by Exposure:PRE-EXISTING CONDITIONS WHICH MAY
BE AGGRAVATED BY MECHANICAL IRRITANTS UPON INHALATION OR SKIN
CONTACT.
* First Aid Measures *
First Aid:INHAL: REMOVE FROM EXPOSURE. GET MED HELP IF IRRIT PERSISTS.
IF IRRIT PERSISTS. SKIN: CLEANSE W/SOAP & WATER. GET MED HELP IF
IRRIT P ERSISTS. INGEST: CONSULT MD IF UNUSUAL REACTION IS NOTED.
FIRES: REMOVE TO FRESH AIR, ADMIN OXYGEN & GET MED HELP. INFO FOR
MED PRACTITIONERS: SKIN IRRIT RESPONDS WELL TO MILD HYDROCORTISONE
CREAM.
* Fire Fighting Measures *
Flash Point:NONCOMBUSTIBLE
Extinguishing Media:USE THAT WHICH IS APPLICABLE TO SURROUNDING FIRE.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . TREAT AS RESIDENTIAL BUILDING MATERIALS.
Unusual Fire/Explosion Hazard:FACINGS ON PROD MAY BURN. TAKE CARE TO
NOT LEAVE FACING EXPOS WHEN WORKING CLOSE TO OPEN FLAME. PRODS CNTN
CURED PHENOLIC-BASED BINDER. BINDER & KRAFT (SUPDAT)
* Accidental Release Measures *
Spill Release Procedures:SPILLS: VACUUM DUST DEPOSITS. ACCIDENTAL OR
UNPLANNED RELEASES: CLEAN AREA WITH VACUUM OR WET METHODS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:STORE UNDER COVER TO PROTECT PRODUCT.
Other Precautions:AVOID SPREAD OF FIBER GLASS DUST. FOR ADDITIONAL
PRODUCT SAFETY INFORMATION, INCLUDING DUST RESPIRATOR DATA AND
* Physical/Chemical Properties *
Boiling Pt:B.P. Text:SEE ING 1
Melt/Freeze Pt:M.P/F.P Text:SEE ING 1
Spec Gravity:SEE ING 1
Solubility in Water:SMALL
Appearance and Odor:FIBERS ASSEMBLED INTO TUBES, BLANKETS/BOARDS. PRODS
MAY BE FACED WITH (SUPDAT)
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
HYDROFLUORIC ACID.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
* Disposal Considerations *
Waste Disposal Methods:SCRAP MATERIAL SHOULD BE DISPOSED OF IN A
SANITARY LANDFILL IN ACCORDANCE WITH FEDERAL, STATE AND LOCAL
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WHERE RESPIRATORY PROTECTION IS REQUIRED, USE
Ventilation:PROVIDE DILUTION VENTILATION OR LOCAL EXHAUST TO PREVENT
BUILD-UP OF VAPORS.
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER .
IMPERVIOUS CLOTHING, APRON.
Work Hygienic Practices:WASH HANDS THOROUGHLY AFTER HANDLING,
ESPECIALLY BEFORE EATING OR SMOKING.
Supplemental Safety and Health
MFR TRADE NAME/PART NO:HOUSE & TRIM PAINT, EXPLO HAZ:CNDTNS EMITTING
IRRITANT AND/OR TOXIC GASES. IN CLSD TANKS, WATER/FOAM MAY CAUSE
FROTHING/ERUPTION. MATLS TO AVOID:POTASSIUM. EFTS OF OVEREXP:UNCOO
RDINATION, NAUS, VOMIT, GI DISTURB, SEVABDOM PAIN, APATHY, CNS
DEPRESS, RESP PROBLEMS, INTOXICATION, (ING 9)
* Product Identification *
* Composition/Information on Ingredients *
Fraction by Wt: 1-5%
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:ALUMINUM HYDROXIDE
Fraction by Wt: 1-5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PROPIONIC ACID, 2-METHYL-, MONOESTER WITH
2,2,4-TRIMETHYL-1,3-PENTANEDIOL
Fraction by Wt: 1-5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SILICA (AMORPHOUS SILICA)
Fraction by Wt: 1-5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:TITANIUM OXIDE
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ACRYLIC COPOLYMER
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:WATER
OSHA PEL:N/K
ACGIH TLV:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPDAT:LIVER DMG, KIDNEY DMG, REPROD SYS DMG, PULM EDEMA,
Ingred Name:ING 9:CARD FAILURE, BRAIN DMG, DEATH. SUPP HLTH INFO:OTHER
OF EYES, SKIN & RESPIRATORY TRACT.
Ingred Name:FIRST AID PROC:OCCURS, CONSULT PHYS. EYE:FLUSH IMMED W/LG
TREATMENT. INGEST:OBTAIN MED TREATMENT IMMEDIATELY.
Ingred Name:SPILL PROC:LG SPILLS-SHUT OFF LEAK IF SAFE TO DO SO. DIKE &
PROPERLY.
Ingred Name:OTHER PREC:SURFACES. IF SUCH CNDTNS CANNOT BE AVOIDED, USE
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL:IRRIT OF RESP TRACT,
LUNGS, PRLNGD INHAL MAY LEAD TO MUC MEMB IRRIT, DROW, DIZZ AND/OR
LT HEAD, HDCH, NAUS, GI DISTURB, COUGH, CHOKING SNEEZING, APATHY,
CNS DEPRESS, RESP PROBLEMS, ANESTHEFT/NARCOSIS, DFCLTY OF BRTHG,
BLOOD ABNORMAL, KIDNEY DMG, PNEUMOCONIOSIS, LOSS OF CONSCIOUSNESS.
SKIN:(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:IRRIT. PRLNGD/RPTD CONT CAN CAUSE
DERM. CONT MAY RSLT IN DERMAL ABSORP OF COMPONENT(S) OF THIS PROD
WHICH MAY CAUSE APATHY. EYE:IRRIT. PRLNGD/RPTD CONT CAN CAUSE CONJ,
TEARING, REDNESS, SEV I RRIT/BURNS, CORNEAL INJURY, BLNDNESS.
INGEST:MAY CAUSE MOUTH & THROAT IRRIT, DROW, DIZZ AND/OR LT HEAD,
HDCH, (SUPDAT)
Medical Cond Aggravated by Exposure:EYE, SKIN, RESPIRATORY DISORDERS
ASTHMA-LIKE CONDITIONS, KIDNEY DISORDERS.
* First Aid Measures *
First Aid:INHAL:REMOVE TO FRESH AIR. RESTORE & SUPPORT CONTINUED BRTHG.
GET MED ATTN. HAVE TRAINED PERSON GIVE OXYG IF NEC. GET MED HELP
FOR ANY BRTHG DFCLTY. REMOVE TO FRESH AIR IF INHAL CAUSE EYE
WATERING, HD CH, DIZZ/OTHER DISCOMFORT. GET MED ATTNIF
DISCOMFORT/IRRIT PERSISTS. SKIN:FLUSH W/WATER, THEN WASH THORO
W/SOAP & WATER. REMOVE CONTAMD CLTHG. WASH CONTAMD CLTHG BEFORE
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:DRY CHEMICAL OR FOAM WATER FOG, CARBON DIOXIDE.
Fire Fighting Procedures:NIOSH APPRVD SCBA & FULL PROT EQUIP . WATER
MAY BE USED TO COOL & PROTECT EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:VAPS ARE HVR/AIR & MAY TRAVEL LONG DIST
TO SOURCE OF IGNIT & FLASH BACK. CLSD CNTNRS MAY BURST IF EXPOSED
TO EXTREME HEAT/FIRE. MAY DECOMPOSE UNDER FIRE(SUPDAT)
* Accidental Release Measures *
Spill Release Procedures:COMPLY W/ALL APPLIC HLTH & ENVIR REGS. ELIM
ALL SOURCES OF IGNIT. VENTILATE AREA. SPILLS MAY BE COLLECTED
W/ABSORB MATLS. EVAC ALL UNNEC PERS. PLACE COLLECTED MATL IN PROPER
CNTNRS. COMPLETE PERSONAL PROT EQUIP MUST BE USED DURING
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
& OPEN FLAME. KEEP FROM FREEZING. DO NOT STORE IN ALUMINUM CNTNRS.
USE W/ADEQ VENT. DO NOT TAKE INTERNALLY.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. AVOID CONT W/SKIN &
EYES, & BRTHG OF VAPS. KEEP CNTNRS TIGHTLY CLSD & UPRIGHT WHEN NOT
IN USE. AVOID CNDTNS WHICH RSLT IN FORMATION OF INHALABLE PARTICLES
* Physical/Chemical Properties *
Evaporation Rate & Reference:NOT KNOWN
Solubility in Water:NOT KNOWN
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZERS, ACIDS, BASES, ALKALIS ALUMINUM, ZINC, HYPOCHLORITES,
HYDROGEN FLUORIDE, MAGNESIUM, CAUSTICS, SODIUM, (SUPDAT)
Stability Condition to Avoid:ELEVATED TEMPS, CONT W/OXIDIZING AGENT,
ALUMINUM OR ZINC, STOR NEAR ACIDS, FREEZING, SPKS, OPEN FLAME,
IGNIT SOURCES.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
OXIDES OF NITROGEN, ACRID FUMES, OXYGEN, TOXIC GASES.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE AND LOCAL REGULATIONS. AVOID DISCHARGE TO NATURAL
WATERS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR FITTED POS PRESSURE AIR SUPPLD RSPRTR
RSPRTR THAT RSPRTR MFR RECOMMENDS FOR ISOCYANATES. WEAR DURING
MIXING, SPRAYING & UNTIL VAP OR/MIST GONE. FOLLOW MFR DIRECTIONS.
Ventilation:PROVIDE GEN DILUTION & LOCAL EXHAUST (PATTRN/VOL) TO
MAINTAIN CONC OF HAZARDOUS SUBSTANCES BELOW TLV/PEL.
Other Protective Equipment:AS REQUIRED TO PREVENT SKIN CONTACT.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
ACTIVATOR IS ONE PART OF 2 COMPONENT MIXTURE. INTENDED TO BE MIXED
W/BASE. CONTENTS OF PACKAGE MUST BE BLENDED W/OTHER COMPONENTS
BEFORE PROD USED. BEFORE OPENING PCKGS, BE SURE TO UNDERSTAND
WARNING MESSAGES & LABELS OF ALL COMPONENTS, SINCE THE MIXTURE MAY
HAVE HZD OF ALL ITS PARTS. FOLLOW PRECAUTIONS.
* Product Identification *
Kit Part:Y
Preparer's Name:W A ELLISON
* Composition/Information on Ingredients *
Other REC Limits:NONE SPECIFIED
Ingred Name:1,6 HEXANE METHYLENE DIISOCYANATE (RESIN)
Fraction by Wt: <5%
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:POLYMERIC HEXAMETHYLENE DIISOCYANATE (RESIN)
Other REC Limits:MFR:1 MG/CU.M
Other REC Limits:NONE SPECIFIED
Other REC Limits:NONE SPECIFIED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:INGEST: MAY BE FATAL. GI IRRIT.
ASPIRATION OF MAT'L INTO LUNGS MAY CAUSE CHEM PNEUMONITIS-CAN BE
FATAL. INHAL: HARMFUL/FATAL, LUNG DAMAGE, LUNG IRRIT, ALLERGIC RESP
REACTION. MAY BE PERMANENT. EYE: SE VERE IRRIT. SKIN: PRIMARY
IRRIT, SENSITIZATION (ALLERGIC REACTION). PERMANENT BRAIN & NERVOUS
SYSTEM DAMAGE.
Effects of Overexposure:INGEST: NAUSEA, VOMITING. OVEREXPOSURE:
ASTHMA-LIKE SYMPTOMS.
Medical Cond Aggravated by Exposure:N/K NOTE TO PHYSICIAN: ANY
TREATMENT THAT MIGHT BE REQUIRED FOR OVEREXPOSURE SHOULD BE
DIRECTED AT THE CONTROL OF SYMPTOMS AND THE CLINICAL CONDITIONS.
* First Aid Measures *
First Aid:INGEST: DON'T INDUCE VOMITING. CALL POISON CONTROL CTR, HOSP
EMERG RM OR DR IMMEDIATELY. INHAL: REMOVE TO FRESH AIR IMMED. IF NO
BREATHING, GIVE ARTIF RESPIRATION. KEEP WARM & QUIET. GET MED AID
AID. SKIN: REMOVE CONTAM CLOTHING. WASH W/SOAP AND WATER. GET MED
AID IF IRRIT PERISISTS.
* Fire Fighting Measures *
Lower Limits:1.7
Upper Limits:7.6
Extinguishing Media:NFPA CLASS B FIRE EXTINGUISHERS (CO2, DRY CHEMICAL
OR ALCOHOL FOAM) FOR LIQ FIRES. POLYMER FOAM PREFFERED FOR LRG
FIRES.
Fire Fighting Procedures:WEAR SCBA. WATER MAY BE INEFFECTIVE, MAY BE
USED TO COOL (FOG NOZZLES PREFERRED) EXPOSED CNTNRS TO PREVENT
PRESSURE BLDUP, AUTOIGNIT OR EXPLOS(W/EXPOS TO HEAT).
Unusual Fire/Explosion Hazard:OVEREXPOSURE TO DECOMP PROD MAY CAUSE
HEALTH HAZARD. SYMPTOMS MAY NOT BE IMMEDIATELY APPARENT. OBTAIN MED
ATTENTION. WARNING: FLAMMABLE.
* Accidental Release Measures *
AREA. ELIM IGNIT SOURCES. DIKE & CONTAIN SPILL W/INERT MAT'L.
TRANSFER LIQ FOR RECOVERY/DISPOSAL (OR REMOVE W/INERT ABSORB) TO
COVERED METAL CNTNR. USE N ON-SPARK TOOLS. PREVENT CONTAM OF
WATERBODIES.
*Handling and Storage *
SKIN/CLOTH. CLOSE CNTNR AFTER USE. PRODUCT *
Other Precautions:* SHOULD NOT BE USED BY THOSE W/BREATH
PROBLEMS/ISOCYANATE REACTION. KEEP FROM HEAT/IGNIT SOURCE. USE
W/VENT. DON'T WASH/REUSE EMPTY CNTNR. DON'T WELD, CUT, BRAZE EMPTY
CNTNRS. GRND/BOND CNTNRS. NEVER USE PRESSURE TO EMPTY-NOT PRESS
VESSEL.
* Physical/Chemical Properties *
HCC:F2
Vapor Density:> AIR
Spec Gravity:1.1
pH:4-7STD
Evaporation Rate & Reference:SLOWER THAN DIETHYL ETHER
Solubility in Water:SLIGHT IN WATER
Appearance and Odor:LIQUID, SOLVENT ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS OR ALKALINE MATERIALS. OXIDIZING MATERIALS.
OF IGNITION.
Hazardous Decomposition Products:BURNING, INCLUDING WHEN HEATED BY
WELD/CUT, WILL PRODUCE SMOKE, CO, CO2, OXIDES OF NITROGEN MAY BE
GENERATED.
* Disposal Considerations *
Waste Disposal Methods:INCINERATE ONLY IN EPA PERMITTED FACILITY. DO
NOT INCINERATE CLOSED CNTNRS. OBSERVE PRECAUTIONS FOR DISPOSAL OF
FLAMMABLE MAT'LS. CONTAM ABSORBENT MAY BE DISPOSED IN HAZARDOUS
WASTE LANDFILL. DISPOSE IN ACCORDANCE W/FED, STATE & LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NONE SHOULD BE NEEDED.
SHOULD BE USED. VENTILATION RATES SHOULD BE MATCHED TO CONDITIONS
Other Protective Equipment:EYE BATH, SAFETY SHOWER, WASHING FACILITIES.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
NONE
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:WATER
Other REC Limits: RECOMMENDED
Ingred Name:DIETHYLENE GLYCOL
Other REC Limits: RECOMMENDED
Ingred Name:POTASSIUM SULFITE
Other REC Limits: RECOMMENDED
Ingred Name:POTASSIUM CARBONATE
Fraction by Wt: 1-5%
Other REC Limits: RECOMMENDED
Fraction by Wt: 3%
Other REC Limits: RECOMMENDED
OSHA PEL:2 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: EXPECTED TO BE A LOW
HAZARD FOR RECOMMENDED HANDLING. EYES: CAUSES IRRITATION. SKIN:
CAUSES IRRITATION. MAY CAUSE ALLERGIC SKIN REACTION. INGESTION:
EXPECTED TO BE A LOW INGESTION HAZARD. MAY CAUSE IRRITATION OF THE
GASTROINTESTINAL TRACT.
Explanation of Carcinogenicity:NO INGREDIENT OF A CONCENTRATION OF 0.1%
OR GREATER IS LISTED AS A CARCINOGEN OR SUSPECTED CARCINOGEN.
Effects of Overexposure: SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure: SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INHALATION-IF SYMPTOMATIC, MOVE TO FRESH AIR. GET MEDICAL
ATTENTION IF SYMPTOMS PERSIST. EYES-IMMEDIATELY FLUSH WITH PLENTY
SOILED C LOTHES/SHOES & WASH WITH SOAP & WATER. IF SKIN IRRITATION
DEVELOPS, GET MEDICAL ATTENTION. INGESTION-DRINK ONE TO TWS GLASSES
OF WATER. SEEK MEDICAL ATTENTION.
* Fire Fighting Measures *
Flash Point:
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL, ALCOHOL
FOAM.
Fire Fighting Procedures:FIRE OR EXCESSIVE HEAT MAY PRODUCE HAZARDOUS
DECOMPOSITION PRODUCTS.
Unusual Fire/Explosion Hazard:
* Accidental Release Measures *
Spill Release Procedures:FLUSH TO SEWER WITH LARGE AMOUNTS OF WATER.
ABSORB SPILL WITH VERMICULITE OR OTHER INERT MATERIAL, THEN PLACE
IN A CONTAINER FOR CHEMICAL WASTE. CLEAN SURFACE THOROUGHLY TO
REMOVE CONTAMINATION.
Neutralizing Agent: SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED. KEEP
AWAY FROM INCOMPATIBLE SUBSTANCES.
Other Precautions:AVOID CONTACT WITH EYE, SKIN OR CLOTHING. USE WITH
ADEQUATE VENTILATION. WASH THOROUGHLY AFTER HANDLING.
* Physical/Chemical Properties *
HCC:N1
Vapor Density:0.6
Solubility in Water:COMPLETE
Appearance and Odor:LIQUID, LIGHT YELLOW COLOR, SLIGHT ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG ACIDS.
Stability Condition to Avoid:STABLE.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
OXIDES OF SULFUR.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
* Disposal Considerations *
Waste Disposal Methods:DISCHARGE, TREATMENT, OR DISPOSAL MAY BE SUBJECT
TO NATIONAL, STATE, OR LOCAL LAWS. FLUSH TO SEWER WITH LARGE
AMOUNTS OF WATER.
| 1 | eyes_protection_mandatory |
Control Measures
*
Product ID: SUPER LUBE GREASE
Proprietary Ind: Y
*
Contractor Summary
*
*
Ingredients
*
-----------------------------
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: NO EVIDENCE OF ADVERSE EFFECT FROM AVAILABLE INFORMATION
ON SWALLOWING. SKIN ABSORPTION AND INHALATION MAY CAUSE SLIGHT IRRITATION IN
CONTACT WITH SKIN AND EYES. CONTACT WITH EYE MAY RESULT IN SLIGHT
IRRITATION. PROLONGED OR REPEATED SKIN CONTACT MAY CAUSE DERMATITIS.
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: NOT ESTABLISHED.
First Aid: INGEST:CALL MD IMMEDIATELY (FP N). INHAL:REMOVE TO FRESH AIR.
SUPPORT BREATHING (GIVE O*2/ARTF RESP) (FP N). SKIN:REMOVE BY WIPING &
WASH W/SOAP & WATER. EYES:WASH W/COPIOUS AMOUNTS OF WATER FOR AT LE AST
*
Handling and Disposal
*
Spill Release Procedures: SPILLS SHOULD BE ABSORBED OR SCRAPED UP.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS (FP N). USE METHOD OUTLINED IN LOCAL EPA & GOVERNMENTAL
REGULATIONS.
Handling And Storage Precautions: GOOD MANUFACTURING PRACTICES SHOULD BE
FOLLOWED IN HANDLING & STORAGE.
Other Precautions: SURFACE SUBJECT TO SPILLS W/THIS PRODUCT CAN BECOME
SLIPPERY.
*
Fire and Explosion Hazard Information
*
Flash Point Method: COC
Extinguishing Media: CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: NONE KNOWN.
*
*
Respiratory Protection: NIOSH APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF
CONCERN (FP N). NONE REQUIRED.
Ventilation: LOCAL EXHAUST: YES.
Other Protective Equipment: EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET ANSI
DESIGN CRITERIA (FP N).
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: NONE SPECIFIED BY MANUFACTURER.
*
Physical/Chemical Properties
*
Solubility in Water: NOT SOLUBLE
Appearance and Odor: WHITE GREASE.
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: NONE KNOWN.
Materials To Avoid: MAY REACT W/STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products: BURNING MAY PRODUCE CARBON MONOXIDE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
HAZCOM Label
*
Product ID: SUPER LUBE GREASE
Company Name: SYNCO CHEMICAL CORP
Label Required IND: Y
Status Code: C
Origination Code: G
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: ACUTE:SKIN ABSORPTION AND INHALATION MAY CAUSE SLIGHT
IRRITATION IN CONTACT WITH SKIN AND EYES. CONTACT WITH EYE MAY RESULT IN
SLIGHT IRRITATION. PROLONGED OR REPEATED SKIN CONTACT MAY CAUSE DERMATITI S.
CHRONIC:NONE LISTED BY MANUFACTURER.
*
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:A CANISTER-TYPE RESPIRATOR MUST BE WORN TO
PREVENT INHALATION OF VAPORS OR SPRAY MISTS WHEN THE TLV PEL IS
EXCEEDED.
Ventilation:USE GENERAL VENT DURING NORMAL USE. LOCAL VENT MAY BE REQ'D
IN CERTAIN CASES TO KEEP EXPOSURE LEVEL BELOW LISTED LIMITS.
Other Protective Equipment:WEAR PROTECTIVE CLOTHING TO PREVENT SKIN
CONTACT. EYE WASH STATION & SAFETY SHOWER SHOULD BE AVAILABLE.
Work Hygienic Practices:LAUNDER CONTAMINATED CLOTHING PRIOR TO REUSE.
USE GOOD PERSONAL HYGIENE.
Supplemental Safety and Health
CAUTION! FLAMMABLE.
* Product Identification *
Product ID:STAIN, OIL, SEMI-TRANSPARENT, WOOD, EXT, LT
Preparer's Name:D KIER
CAGE:0ALO9
CAGE:0ALO9
* Composition/Information on Ingredients *
Other REC Limits:NONE SPECIFIED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: EXCESSIVE:
NASAL/RESPIRATORY IRRITATION. SKIN: PROLONGED/REPEATED: DEFATTING.
EYE: SEVERE IRRITATION. INGESTION: GI TRACT IRRITATION. ASPIRATION
OF MATERIAL INTO LUNGS CAN CAUSE CHEMICAL P NEUMONITIS WHICH CAN BE
FATAL. REPORTS ASSOCIATE OVEREXPOSURE TO SOLVENTS W/PERM BRAIN &
NERV SYS DAMAGE. HARMFUL/FATAL.
Effects of Overexposure:INHALATION: DIZZINESS, WEAKNESS, FATIGUE,
NAUSEA, HEADACHE, POSSIBLE UNCONSCIOUSNESS, ASPHYXIATION. EYE:
REDNESS, TEARING, BLURRED VISION. INGESTION: NAUSEA, VOMITING,
DIARRHEA.
* First Aid Measures *
First Aid:INHALATION: REMOVE VICTIM FROM FURTHER EXPOSURE & RESTORE
MIN WHILE HOLDING EYE LIDS OPEN. SKIN: WASH CONTAMINATED SKIN
W/MILD SOAP & WATER. INGESTITON: DO NOT INDUCE VOMITING. OBTAIN
MEDICAL ATTENTION IMMEDIATELY.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:0.8
Upper Limits:5.0
Extinguishing Media:DRY CHEMICAL, CO2, FOAM, AND WATER FOG.
Fire Fighting Procedures:DON'T ENTER CONFINED FIRE SPACE W/OUT
PROTECTIVE CLOTHING & POSITIVE PRESSURE SCBA. EXLUDE AIR. DON'T USE
WATER EXCEPT AS FOG. USE WATER TO COOL EXPOSED CNTNRS.
Unusual Fire/Explosion Hazard:AVOID EXCESSIVE HEAT, OPEN FLAMES AND ALL
IGNITION SOURCES. VAPOR FORMS AN EXPLOSIVE MIXTURE WITH AIR BETWEEN
UPPER AND LOWER FLAMMABLE LIMITS.
* Accidental Release Measures *
Spill Release Procedures:REMOVE IGNITE SOURCES. VENT AREA. ABSORB SPILL
W/ABSORBENT & PLACE IN CLOSED CNTNR. LRG SPILL: DIKE AREA TO
PREVENT MAT'L FROM ENTERING WATER SYSTEMS/SEWERS. WEAR PROTECT
EQUIPMENT DURING CLEAN UP. NO TIFY APPROPRIATE AGENCY IF SPILL
*Handling and Storage *
Handling and Storage Precautions:COMBUSTIBLE LIQUID. STORE IN COOL,
DRY, VENTILATED AREA. AWAY FROM HEAT & IGNITION SOURCES. AVOID
PROLONGED/REPEATED CONTACT W/SKIN.
Other Precautions:AVOID BREATHING VAPORS & MIST. GROUND CONTAINERS WHEN
POURING & LIMIT FREE FALL. EMPTY CONTAINERS MAY BE HAZARDOUS FROM
PRODUCT RESIDUES & VAPOR. DO NOT TAKE INTERNALLY. CLOSE CONTAINER
AFTER EACH USE . KEEP FROM CHILDREN.
* Physical/Chemical Properties *
Vapor Density:4.8
Evaporation Rate & Reference:LESS THAN N-BUTYL ACETATE
Solubility in Water:NEGLIGIBLE
Appearance and Odor:THIN LIQUID, MILD ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS, LEWIS OR MINERAL ACIDS.
Stability Condition to Avoid:AVOID EXCESSIVE HEAT, OPEN FLAME & ALL
IGNITION SOURCES.
Hazardous Decomposition Products:CARBON MONOXIDE AND CARBON DIOXIDE ARE
PRODUCED ON COMBUSTION.
* Disposal Considerations *
OF AT LICENSED WASTE DISPOSAL COMPANY OR INCINERATE W/APPROVAL OF
ENVIRON AUTHORITY. ALL DISPOSAL PROCEDURES MUST COMPLY W/LOCAL,
STATE AND FEDERAL REG ULATIONS.
| 1 | eyes_protection_mandatory |
Control Measures
*
Proprietary Ind: Y
*
Contractor Summary
*
*
Ingredients
*
-----------------------------
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE: MAY CAUSE DERMATITIS, SHORTNESS OF BREATH,
FAINTING, HEADACHES AND NAUSEA. CHRONIC: REPEATED OR PROLONGED SKIN CONTACT
MAY CAUSE SENSITIZATION. IRRITANCY OF PRODUCTS: MODERATE EYE AND SKIN IRRI
TANT, INHALATION OF VAPORS OR MISTS MAYCAUSE IRRITATION OF THE RESPIRATORY
TRACT. SENSITIZATION TO (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: HLTH HAZ: PRODUCT: CAN CAUSE AN ALLERGIC
REACTION. SYNERGISTIC PRODUCTS: THE USE OF CERTAIN ALCOHOLS IN CONJUNCTION
WITH THIS PRODUCT CAN INCREASE THE RISK OF SKIN IRRITATION AND/OR
SENSITIZATION AS T HEY REMOVE THE PROTECTIVE OILS ON THE SKIN.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: EYE:IMMED WASH W/COPIOUS AMTS OF H*2O, OCCAS LIFTING THE LOWER &
WASH THE AREA WITH SOAP & H*2O & FLUSH W/H*2O. IF THE MATL GETS ON
CLTHG, REMOVE THE CLTHG & WASH THE AFFECTED AREA W/SOAP & H*2O. IF
IRRIT DEVELOPS, GET MED ATTN. DISCARD/WASH CONTAMD CLTHG BEFORE REUSE.
INGEST:DILUTE W/MILK/H*2O IF VICTIM IS (SUPDAT)
*
Handling and Disposal
*
Spill Release Procedures: CONTAIN MATERIAL WITH ABSORBENTS. PLACE IN CONTAINER
FOR DISPOSAL. CLEAN UP WITH SOAP AND WATER AND FLUSH AREA WITH WATER.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: MATERIAL MAY BE CURED SOLID BY EXPOSURE TO U.V LIGHT.
CURED MATERIAL MAY BE DISPOSED OF IN LANDFILL. COMPLY WITH ALL FEDERAL, STATE
AND LOCAL REGULATIONS.
Handling And Storage Precautions: DO NOT REUSE CONTAINER. THIS PRODUCT IS FOR
Other Precautions: NONE SPECIFIED BY MANUFACTURER.
*
Fire and Explosion Hazard Information
*
Flash Point Method: OC
Extinguishing Media: CARBON DIOXIDE, FOAM, DRY CHEMICAL.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: NONE SPECIFIED BY MANUFACTURER.
*
*
Respiratory Protection: NOT REQ UNDER NORM OPERATING CNDTNS. RESP PROT MAY BE
NEEDED UNDER CERTAIN CNDTNS WHERE SIGNIFICANT EXPOS TO FUMES/MISTS MAY OCCUR.
AN AIR PURIFYING RESP EQUIP W/ORG VAP CARTRIDGES IS REC. SELECTION A ND USE
MUST (SUPDAT)
Ventilation: USE LOCAL AND MECHANICAL EXHAUST TO MINIMIZE EXPOSURE TO VAPORS OR
MISTS.
Other Protective Equipment: EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET ANSI
DESIGN CRITERIA (FP N). LEATHER SHOES. CLOTHING:COVER ARMS AND LEGS.
Work Hygienic Practices: PRACTICE GOOD HOUSEKEEPING AND VIGOROUS PERSONAL
HYGIENE TO MINIMIZE CONTACT WITH MATERIAL.
Supplemental Safety and Health: USERS OF "L" VERSION OF SHOULD CONSULT "LR"
VERSION FOR ADDITIONAL INFO (FP N). FIRST AID PROC: ALERT. SEE DOCTOR AS SOON
AS POSSIBLE. INHAL:IF OVERCOME BY VAPORS/FUMES, REMOVE TO FRESH AIR. GET
MEDICAL ATTENTION IF SYMPTOMS PERSIST. RESP PROT:COMPLY W/ANY EXISTING
FEDERAL STANDANDS FOR RESPIRATORY PROTECTION.
*
Physical/Chemical Properties
*
Vapor Density: >1
Spec Gravity: 1.2 (H*2O = 1)
Appearance and Odor: CLEAR LIQUID; SULFUROUS ODOR.
Percent Volatiles by Volume: <.1
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
CAUSE A NONHAZARDOUS POLYMERIZATION REACTION.
Hazardous Decomposition Products: COULD GENERATE CARBON MONOXIDE AND HYDROGEN
SULFIDE. A SMALL AMOUNT OF HCN WILL BE GENERATED AT INCOMPLETE COMBUSTION.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
HAZCOM Label
*
Company Name: NORLAND PRODUCTS INC
Label Required IND: Y
Status Code: C
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: Slight
Reactivity Hazard: Slight
Hazard And Precautions: ACUTE: MAY CAUSE DERMATITIS, SHORTNESS OF BREATH,
FAINTING, HEADACHES AND NAUSEA. EYE, SKIN, AND RESPIRATORY TRACT IRRITANT.
CHRONIC: REPEATED OR PROLONGED SKIN CONTACT MAY CAUSE SENSITIZATION.
*
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF THIS PRODUCT IS SANDED OR MACHINED AFTER
CURING TAKE APPROPRIATE PRECAUTIONS AGAINST AGAINST INHALATION OF
Ventilation:GENERAL MECHANICAL, VENT IS ADEQUATE FOR OCCASIONAL USE.
FOR PROLONGED/REPEATED USE, LOCAL EXHAUST IS RECOMMENDATION.
Other Protective Equipment:CHEMICAL RESISTANT RUBBER (FOR EXAMPLE,
NEOPRENE) PROTECTIVE GEAR AS NEEDED TO PREVENT SKIN CONTACT.
Supplemental Safety and Health
* Product Identification *
Kit Part:Y
* Composition/Information on Ingredients *
Ingred Name:TRIETHYLENETETRAMINE (TETA) (SKIN & EYE IRRITANT;
RESPIRATORY IRRITANT; SENSITIZER)
Other REC Limits:NONE SPECIFIED
IRRITANT)
Other REC Limits:NONE SPECIFIED
Ingred Name:AMINOETHYL PIPERAZINE ADDUCT (SKIN IRRITANT; EYE IRRITANT)
Other REC Limits:NONE SPECIFIED
Ingred Name:AMINOETHYLPIPERAZINE (AEP) (SKIN IRRITANT; SEVERE EYE
IRRITANT)
Fraction by Wt: 1-5%
Other REC Limits:NONE SPECIFIED
Ingred Name:NONYL PHENOL (SKIN IRRITANT; SEVERE EYE IRRITANT)
Fraction by Wt: 1-5%
Other REC Limits:NONE SPECIFIED
Ingred Name:VOC: 0 LBS/GAL
Other REC Limits:NONE SPECIFIED
* Hazards Identification *
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: SEVERE IRRITANT. SKIN: MODERATE
IRRITANT. INHALATION: IRRITATION OF NOSE AND THROAT; NAUSEA AND
VOMITING IN SEVERE CASES. INGESTION: MAY CAUSE IRRITATION OF MOUTH
AND THROAT AND GASTROINTESTINAL TRACT. REPEATED SKIN CONTACT OR
INHALATION OF FUMES CAN CAUSE SENSITIZATION.
Effects of Overexposure:SENSITIZATION: ITCHING, RASHES, SWELLING OF
SKIN OR AN ASTHMA-LIKE RESPIRATORY REACTION ON LATER EXPOSURE TO
Medical Cond Aggravated by Exposure:ASTHMA, BRONCHITIS, OR SKIN
IRRITATIONS.
* First Aid Measures *
OPEN. GET MED HELP AS SOON AS POSSIBLE. SKIN: IMMED REMOVE CONTAM
CLOTHING & SHOES & WASH WELL W/SOAP & WARM WATER. SEE DOCTOR IF
IRRIT DEV ELOPS. INHAL: REMOVE PATIENT TO FRESH AIR. GIVE
OXYGEN/ARTIF RESPIRATION IF NEEDED. SEE DOCTOR IF SYMPTOMS PERSIST.
INGEST: DON'T INDUCE VOMITING. DILUTE W/LOTS OF MILK/WATER & GET
IMMED MED HELP.
* Fire Fighting Measures *
Flash Point Method:TCC
Extinguishing Media:WATER, CO2, DRY CHEMICAL.
Fire Fighting Procedures:FIREFIGHTERS SHOULD WEAR SELF-CONTAINED
BREATHING APPARATUS AND SUFFICIENT PROTECTIVE GEAR TO PREVENT ALL
SKIN AND EYE CONTACT WITH THIS MATERIAL.
Unusual Fire/Explosion Hazard:NONE.
* Accidental Release Measures *
Spill Release Procedures:PREVENT SKIN & EYE CONTACT; REMOVE
CONTAMINATED CLOTHING & SHOES. ABSORB SPILL ON INERT MATERIAL SUCH
AS VERMICULITE; SCRAPE UP AND TRANSFER TO IMPERVIOUS CONTAINERS.
SCRUB SPILL AREA WITH STRONG DETE RGENT & WATER.
*Handling and Storage *
Handling and Storage Precautions:STORE WELL-CLOSED IN COOL, DRY PLACE.
REMOVE CONTAM CLOTH & LAUNDER BEFORE USING. CONTAM LEATHER ARTICLES
(SHOES, BELTS) CAN'T BE DECONTAM/DESTROYED.
Other Precautions:PROLONGED OR REPEATED EXPOSURE MAY CAUSE
SENSITIZATION AND ALLERGIC RESPONSE. THOSE SO AFFECTED SHOULD
CONSULT A PHYSICIAN/AVOID FURTHER EXPOSURE TO MAT'L IF SENSITIZED.
THIS PRODUCT HAS BEEN TESTED F OR CORROSIVITY. IT IS NOT CORROSIVE.
* Physical/Chemical Properties *
HCC:N1
Vapor Density:>1
Evaporation Rate & Reference:<<1 (BU AC=1)
Appearance and Odor:WHITE PASTE WITH MILD AMMONIA-LIKE ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, ACIDS, AND CHLORINATED ORGANIC COMPOUNDS.
Stability Condition to Avoid:EXTREME HEAT, OPEN FLAME.
Hazardous Decomposition Products:ACRID AND TOXIC FUMES WITH ORGANIC
AMINES, AMMONIA, OXIDES OF CARBON AND NITROGEN.
Conditions to Avoid Polymerization:HEAT IS RELEASED WHEN THIS PRODUCT
IS MIXED WITH EPOXY RESINS; USE CARE WHEN MIXING LARGE QUANTITIES.
* Disposal Considerations *
Waste Disposal Methods:KEEP OUT OF PUBLIC WATER SUPPLIES. INCINERATE IN
APPROVED FACILITY WHERE PERMITTED BY STATE AND LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WEAR APPROPRIATE NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:USE ONLY IN A CHEMICAL FUME HOOD.
Other Protective Equipment:SAFETY SHOWER, EYE BATH
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH THOROUGHLY AFTER HANDLING. REMOVE/DISCARD CONTAMINATED
SHOES.
Supplemental Safety and Health
* Product Identification *
* Composition/Information on Ingredients *
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:HARMFUL IF SWALLOWED, INHALED/ BY SKIN
ABSORPTION. EXTREMELY DESTRUCTIVE TO TISSUE OF THE MUCOUS MEMBRANES
& UPPER RESPIRATORY TRACT, EYES/SKIN. INHALATION: MAY RESULT IN
SPASM, INFLAMMATION & EDEMA O F THE LARYNX/BRONCHI, CHEMICAL
PNEUMONITIS & PULMONARY EDEMA. MUTAGENIC. CAUSES BURNS. POSSIBLE
IRREVERSIBLE EFFECTS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INFLAMMATION, BURNING SENSATION, COUGHING,
WHEEZING, LARYNGITIS, SHORTNESS OF BREATH, HEADACHE, NAUSEA,
VOMITING, BURNS
* First Aid Measures *
First Aid:EYES/SKIN: IMMEDIATELY FLUSH W/COPIOUS AMOUNTS OF WATER FOR
NECESSARY. INGESTION: WASH OUT MOUTH W/WATER IF CONSCIOUS. OBTAIN
MEDICAL ATTEN TION IN ALL CASES.
* Fire Fighting Measures *
Extinguishing Media:CO2, DRY CHEMICAL POWDER/APPROPRIATE FOAM
Fire Fighting Procedures:WEAR A SELF CONTAINED BREATHING APPARATUS &
PROTECITVE CLOTHING TO PREVENT CONTACT W/SKIN & EYES.
Unusual Fire/Explosion Hazard:EMITS TOXIC FUMES UNDER FIRE CONDITIONS.
* Accidental Release Measures *
Spill Release Procedures:EVACUATE AREA. WEAR SELF CONTAINED BREATHING
LIME/SODA ASH, PICK UP, KEEP IN A CLOSED CONTAINER & HOLD FOR WASTE
DISPOSAL. VENTILATE AREA & W ASH SITE AFTER MATERIAL PICKUP IS
COMPLETE.
*Handling and Storage *
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE. KEEP
TIGHTLY CLOSED. HYGROSCOPIC. WEAR SUITABLE PROTECTIVE CLOTHING,
Other Precautions:DON'T BREATHE DUST. DON'T GET IN EYES, ON SKIN/ON
CLOTHING. AVOID PROLONGED/REPEATED EXPOSURE.
* Physical/Chemical Properties *
Appearance and Odor:WHITE POWDER & CHUNKS
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG BASES, ACID CHLORIDES, ACID ANHYDRIDES
Stability Condition to Avoid:FIRE, MOISTURE
Hazardous Decomposition Products:NITROGEN OXIDES, SULFUR OXIDES
* Disposal Considerations *
Waste Disposal Methods:DISSOLVE/MIX THE MATERIAL W/A COMBUSTIBLE
SOLVENT & BURN IN A CHEMICAL INCINERATOR EQUIPPED W/AN AFTERBURNER
& SCRUBBER. DISPOSE OF IAW/LOCAL, STATE & FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:WHEN ENGINEERING OR ADMINISTRATIVE CONTROLS ARE
NOT FEASIBLE TO CONTROL OVEREXPOSURE OR WHILE THEY ARE BEING
INSTITUTED, APPROPRIATE NIOSH/MSHA APPROVED RESPIRATORS SHALL BE
Ventilation:LOCAL EXHAUST VENT SHOULD BE USED TO KEEP EXPOSURE BELOW
EXPOSURE LIMITS DURING WELDING AND GRINDING OPERATIONS.
Other Protective Equipment:APPROPRIATE AND AS NEEDED TO PROTECT AGAINST
EXPOSURE TO CHEMICAL OR PHYSICAL HAZARDS.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EFTS OF OVEREXP:& THUS MAY CAUSE ALLERGIC RXNS. EXCESSIVE & PRLNGD
INHAL OF MANGANESE CAN (GENERALLY OVER 2 YEARS EXPOSURE) CAUSE DMG
TO THE CNS. SPECIFICALLY, THE PATHOLOGY RESEMBLES PARKINSON'S DISE
ASE. INDUST EXPOS TO COPPER FUMES, DUSTS OR MISTS RSLTS IN METAL
FUME FEVER W/ATROPHIC CHANGES IN NASAL MUCOUS (ING 6)
* Product Identification *
Preparer's Name:W. R. BELL
* Composition/Information on Ingredients *
Ingred Name:NICKEL (SARA III)
OSHA PEL:1 MG/M3
Ingred Name:CHROMIUM (SARA III)
Fraction by Wt: <0.6%
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:MANGANESE (SARA III)
OSHA PEL:(C) 5 MG/M3 DUST
Ingred Name:SILICON
Ingred Name:IRON (III) OXIDE; (IRON)
Ingred Name:SUPP DATA:MEMB. CHRONIC POISONING RSLTS IN WILSON'S
DISEASE, CHARACTERIZED BY A HEPATIC CIRRHOSIS, BRAIN DMG, (ING 7)
Ingred Name:ING 6: DEMYELINATION, RENAL DISEASE AND COPPER DEPOSITION
IN THE CORNEA.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: EXCESSIVE INHALATION OF FUMES
FROM MANY METALS CAN PRODUCE AN ACUTE REACTION KNOWN AS "METAL FUME
FEVER". THOUGH METALS SUCH AS COPPER AND ZINC HAVE BEEN MOST
ASSOCIATED WITH METAL FUME FEVER, IT IS SUPECTED BY SOME
AUTHORITIES THATOTHER METALLIC FUMES MAY PRODUCE THIS CONDITION.
SYMPTOMS (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NICKEL: ANTICIP TO BE CARCIN (NTP 6TH
Effects of Overexposure:HLTH HAZ:CONSIST OF CHILLS & FEVER (VERY
SIMILAR TO & EASILY CONFUSED W/FLU SYMPTOMS), WHICH COME ON A FEW
HRS AFTER LARGE EXPOSURE. LONG-TERM EFFECTS OF METAL FUME FEVER
HAVE NOT BEEN NOTED. CHRONIC: EXCESSIVE INHALATION OF NICKEL FUMES
HAS BEEN ASSOC W/RESP CANCER. ALSO, NICKEL IS A POTENTIAL
SENSITIZER, (SUPP DATA)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INHAL: IF ACUTE EXPOSURE TO FUMES OCCURS, REMOVE VICTIM FROM
THE ADVERSE ENVIRONMENT IMMEDIATELY AND SEEK MEDICAL ATTENTION.
ASSISTANCE F ROM MD . SKIN: FLUSH WITH COPIOUSAMOUNTS OF WATER.
CALL MD . INGEST: GET MD IMMEDIATELY .
* Fire Fighting Measures *
Extinguishing Media:EXTINGUISHING MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
* Accidental Release Measures *
Spill Release Procedures:NONE SPECIFIED BY MANUFACTURER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:ALL OPERATIONS WITH POTENTIALLY HAZARDOUS EXPOSURES
SHOULD BE EVALUATED BY COMPETENT INDUSTRIAL HYGIENIST.
* Physical/Chemical Properties *
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:NO
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
* Disposal Considerations *
Waste Disposal Methods:DISPOSAL MUST BE IN ACORDANCE WITH FEDERAL,
STATE AND LOCAL REGULATIONS .
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE APPROVED CHEMICAL MECHANICAL FILTER
RESPIRATOR.
Other Protective Equipment:EYE WASH, SAFETY SHOWERS
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. SHOWER DAILY & CHANGE CLOTHES INCLUDING UNDERGARMENTS.
Supplemental Safety and Health
* Product Identification *
Kit Part:Y
Preparer's Name:A VELLIS
* Composition/Information on Ingredients *
Ingred Name:COLUMBIA CARBON, CARBON BLACK, LAMPBLACK, BLACK PEARLS
Other REC Limits:3.5 MG/CUM (NIOSH)
OSHA PEL:3.5 MG/CUM
ACGIH TLV:3.5 MG/CUM
Ingred Name:VINYL ACETATE
Ingred Name:BUTANOL, N-BUTYL ALCOHOL, PROPYL CARBINOL, BUTYL ALCOHOL
Ingred Name:ISOPROPANOL (ISOPROPYL ALCOHOL), 2-PROPANOL, DIMETHYL
CARBINOL
Ingred Name:2-BUTANONE (METHYL ETHYL KETONE) (MEK)
Fraction by Wt: 8%
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: IRRITATION OF THE
RESPIRATORY TRACT/ASPHYXIATION. ANESTHETIC. SKIN: SEVERE
IRRITATION/BURNING SENSATION/DERMATITIS. EYES: IRRITATION.
INGESTION: IRRITATION OF THE GASTROINTESTINAL TRACT. M AY CAUSE
DELAYED EFFECTS ON BLOOD, GASTROINTESTINAL, NERVOUS & REPRODUCTIVE
SYSTEM.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:DIZZINESS, NAUSEA, HEADACHE, IRRITATION,
VOMITING, UNCONSCIOUSNESS, ASPHYXIATION, DRYING, CRACKING,
DEFATTING, WATERING, BLURRED VISION, BURNING SENSATION, COMA
Medical Cond Aggravated by Exposure:PREEXISTING HEART, LUNG, LIVER,
KIDNEY & SKIN DISORDERS.
* First Aid Measures *
First Aid:INHALATION: REMOVE FROM EXPOSURE, RESTORE BREATHING. EYES:
WATER. INGESTION: DON'T INDUCE VOMITING. DRINK 1-2 GLASSES OF WATER
TO DILUTE . OBTAIN MEDICAL ATTENTION IN ALL CASES.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:1.2
Extinguishing Media:FOAM, CO2, DRY CHEMICAL, WATER FOG
Fire Fighting Procedures:WEAR FULL PROTECTIVE EQUIPMENT & SCBA. FIGHT
AS VOLATILE FIRE. USE WATER TO COOL FIRE EXPOSED CONTAINERS. FOG
NOZZLES RECOMMENDED. AVOID SPREADING FIRE.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. VAPORS MAY BE MOVED BY VENTILATION/TRAVEL
TO IGNITION SOURCE. ISOLATE FROM ALL SOURCES OF HEAT.(SUPP
* Accidental Release Measures *
Spill Release Procedures:VENTILATE AREA. REMOVE ALL IGNITION SOURCES.
CONTAIN & REMOVE W/INERT ABSORBENT & NON-SPARKING TOOLS. WEAR
PROTECTIVE EQUIPMENT DURING CLEANUP, CONTAIN LIQUID TO PREVENT
CONTAMINATION/SOIL & GROUND WA TER.
*Handling and Storage *
Handling and Storage Precautions:KEEP CLOSURE TIGHT & CONTAINER UPRIGHT
POSITION. STORE AWAY FROM HEAT/IGNITION SOURCES. ALL METAL
CONTAINERS MUST BE GROUNDED/BONDED DURING TRANSFER.
Other Precautions:AVOID PROLONGED BREATHING OF VAPORS, SKIN/EYE
CONTACT. DON'T TAKE INTERNALLY. AVOID CONTACT W/MATERIAL ESPECIALLY
HANDS. EMPTY CONTAINERS MAY EXPLODE DUE TO RESIDUES.
* Physical/Chemical Properties *
Vapor Density:>1
Spec Gravity:0.9
VOC Grams/Liter:5.6
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:VISCOUS LIQUID W/A SOLVENT ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, ACIDS & BASES
Stability Condition to Avoid:HEAT, ELECTRICAL EQUIPMENT, SPARKS, OPEN
FLAME & OTHER IGNITION SOURCES
Hazardous Decomposition Products:CO2, CO, OTHER OXIDES, TOXIC FUMES &
SMOKE
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
* Other Information *
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPRVD FULL FACEPIECE RESP:AIR
PURIFYING OR POWERED AIR PURIFYING WITH HEPA FILTERS; TYPE C,
SUPPLIED AIR OPERATED IN PRESSURE DEMAND MODE.
Ventilation:PROVIDE LOCAL EXHAUST OR GENERAL DILUTION VENTILATION
SYSTEM.
Other Protective Equipment:EMPLOYER SHOULD PROVIDE AN EYEWASH FOUNTAIN
WITHIN IMMEDIATE WORK AREA FOR EMERGENCY USE. IMPERVIOUS CLOTHING &
EQUIP.
Work Hygienic Practices:WASH HANDS FREQUENTLY AND THOROUGHLY DURING
CONTACT WITH MATERIAL AND AT END OF WORKDAY .
Supplemental Safety and Health
FIRE FIGHT PROC:DO NOT SCATTER SPILLED MATL W/MORE WATER THAN NEEDED
FOR FIRE CTL. DIKE FIRE CTL WATER FOR LATER DISP. AVOID HAZ VAPS,
KEEP UPWIND. EFTS OF OVEREXP: INGEST: ACUTE: MAY CAUSE GI IRRIT W
/ABDOM PAIN, NAUS, VOMIT & DIARR. IN SUSCEPTIBLE INDIV, ESP
ASTHMATICS, (SEE INGRED 5)
* Product Identification *
* Composition/Information on Ingredients *
Ingred Name:SODIUM SULFITE
Ingred Name:1ST AID PROC:EYE:WASH EYES W/LARGE AMNTS OF WTR OR NORMAL
SALINE,OCCASIONALLY LIFTING UPPER & LOWER LIDS,UNTIL NO(ING 3)
IMMED.INGEST:TREAT SYMPTOMATICALLY & SUPPORTIVELY.GET MD IMME.(ING
4)
Ingred Name:IF VOMITING OCCURS,KEEP HEAD LOWER THAN HIPS TO PREVENT
ASPIRATION.SUP DATA:SULFITES MAY CAUSE WHEEZING,SHORTNESS(ING 5)
Ingred Name:OF BREATH, UNCON & ANAPHYLAXIS.SIGNS & SYMPTOMS MAY INCLUDE
GEN FLUSHING & ITCHING & RESPIRATORY ARREST.THE ESTIM(ING 6)
CAUSED VIOLENT COLIC & DIARRHEA,CIRCULATORY DISTURBANCES,(ING 7)
Ingred Name:CNS DEPRESSION & DEATH. CHRONIC: RPTD INGEST OF FOOD
CONTAINING SULFITES MAY CAUSE SENSITIZATION.
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL:SENSITIZER. ACUTE:MAY CAUSE MUC
MEMB IRRIT. MAY CAUSE ADVERSE RXNS INCLUDING BRONCHOSPASMS IN
SUSCEPTIBLE INDIVIDUALS, ESPECIALLY ASTHMATICS. SYMPTOMS MAY
INCLUDE FLUSHING, SEV WHEEZING, SWELLIN G OF THROAT, AND PALATAL
AND GENERALIZED ITCHING. CHRONIC: RPTD/PRLNGD EXPOS MAY CAUSE
SENSIT. (SEE EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: SKIN: ACUTE:DIRECT CONT MAY CAUSE
IRRIT & CONT DERMAT. SOME SULFITES MAY CAUSE SENSIT DERMAT IN
PREVIOUSLY EXPOSED INDIVIDUALS. CHRONIC:RPTD/PRLNGD EXPOS MAY CAUSE
CONT DERMAT. RPTD EXPOS TOSULFITES MAY RESULT IN SENSIT. EYE:
ACUTE:DIRECT CONT MAY CAUSE IRRIT & REDNESS. (SEE SUPP DATA)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
* First Aid Measures *
First Aid:INHAL:REMOVE FROM EXPOSURE AREA TO FRESH AIR IMMED. IF
BREATHING HAS STOPPED, PERFORM ARTF RESP. KEEP PERSON WARM AND AT
REST. TREAT SYMPTOMATICALLY AND SUPPORTIVELY. GET MD IMMED.
SKIN:REMOVE CONTAMD CLTHG & SHOES IMMED. WASH AFFECTED AREA W/SOAP
OR MILD DETERGENT & LARGE AMTS OF WATER UNTIL NO EVIDENCE OF CHEM
* Fire Fighting Measures *
Extinguishing Media:DRY CHEMICAL, CARBON DIOXIDE, WATER SPRAY OR FOAM.
FOR LARGER FIRES:USE WATER SPRAY, FOG OR ALCOHOL FOAM.
Fire Fighting Procedures:NIOSH/MSHA APPRVD BREATHING APPARATUS W/FULL
FACEPIECE OPERATED IN PRESS-DEMAND OR OTHER POSITIVE PRESS MODE.
MOVE CNTNR FROM FIRE AREA IF POSS. (SEE SUPP DATA)
Unusual Fire/Explosion Hazard:NEGLIGIBLE FIRE HAZARD WHEN EXPOSED TO
HEAT OR FLAME.
* Accidental Release Measures *
Spill Release Procedures:SWEEP UP AND PLACE IN SUITABLE CLEAN, DRY
CONTAINERS FOR RECLAMATION OR LATER DISPOSAL. DO NOT FLUSH SPILLED
MATERIAL INTO SEWER. KEEP UNNECESSARY PEOPLE AWAY.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
*Handling and Storage *
Handling and Storage Precautions:STORE AWAY FROM INCOMPATIBLE
SUBSTANCES.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
* Physical/Chemical Properties *
Boiling Pt:B.P. Text:DECOMPOSES
Melt/Freeze Pt:M.P/F.P Text:DECOMPOSES
pH:9.0
Appearance and Odor:ODORLESS, WHITE CRYSTALS OR POWDER WITH A SALINE,
SULFUROUS TASTE.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
SODIUM SULFITE:MINERAL ACIDS (STRONG):REACTS TO FORM SULFUR DIOXIDE.
Stability Condition to Avoid:NONE REPORTED.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY RELEASE
TOXIC OXIDES OF SULFUR AND TOXIC SODIUM OXIDE.
* Disposal Considerations *
Waste Disposal Methods:OBSERVE ALL FEDERAL, STATE AND LOCAL REGULATIONS
WHEN STORING OR DISPOSING OF THIS SUBSTANCE. FOR ASSISTANCE,
CONTACT THE DISTRICT DIRECTOR OF THE ENVIRONMENTAL PROTECTION
AGENCY.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:IF TLV IS EXCEEDED, WEAR NIOSH-APPROVED ORGANIC
VAPOR RESPIRATOR OR AIR-PURIFYING RESPIRATOR. IN EMERGENCY, WEAR A
NIOSH-APPROVED POSITIVE-PRESSURE SELF-CONTAINED BREATHING
APPARATUS.
Ventilation:MECHANICAL (GENERAL AND/OR LOCAL EXHAUST, EXPLOSION-PROOF)
VENTILATION TO MAINTAIN EXPOSURE BELOW TLV(S).
Other Protective Equipment:EYE WASH STATION & SAFETY SHOWERS SHOULD BE
AVAILABLE IN THE IMMEDIATE VICINITY OF ANY POTENTIAL EXPOSURE.
Work Hygienic Practices:USE ONLY AS DIRECTED ON LABEL. READ LABEL
BEFORE USING PRODUCT. DO NOT BREATHE VAPORS. WASH HANDS BEFORE
EATING.
Supplemental Safety and Health
FORMULA CHANGED. FOR PREVIOUS FORMULATION, SEE PNI A, SAME NSN.
EXTREMELY FLAMMABLE. CONTENTS UNDER PRESSURE. CONTAINS GAS SIMILAR
TO PROPANE. DO NOT USE IN CONFINED AREA OR AREA WITH LITTLE AIR
MOVEM ENT. EMPLOY MEANS TO PREVENT VAPOR BUILDUP.
* Product Identification *
Product ID:CCC
* Composition/Information on Ingredients *
Ingred Name:METHYL ALCOHOL (METHANOL) (SARA III)
Other REC Limits:NONE RECOMMENDED
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)
Other REC Limits:NONE RECOMMENDED
Ingred Name:DIACETONE ALCOHOL (4-HYDROXY-4-METHYL-2-PENTANONE)
Fraction by Wt: <5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
Other REC Limits:NONE RECOMMENDED
Ingred Name:ACETONE (SARA III)
Other REC Limits:NONE RECOMMENDED
Ingred Name:PROPANE/ISOBUTANE
Other REC Limits:NONE RECOMMENDED
Ingred Name:TOLUENE (SARA III)
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYE, SKIN, CNS, LUNG,
LIVER, KIDNEY. ACUTE- HARMFUL/FATAL IF SWALLOWED. CONTAINS
METHANOL. INGESTION CAN CAUSE BLINDNESS. VAPORS CAN CAUSE HEADACHE,
DIZZINESS, EYE & SKIN IRRITATION. CHR ONIC- MAY CAUSE MENTAL
CONFUSION, DEPRESSION, VOMITING, COUGH, VISUAL DISTURBANCES, LUNG,
LIVER, KIDNEY DAMAGE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES, SKIN, RESPIRATORY TRACT IRRITATION,
HEADACHE, DIZZINESS, NAUSEA, VOMITING, MENTAL CONFUSION,
DEPRESSION, FATIGUE, LOSS OF APPETITE, COUGH, LOSS OF SENSES OF
BALANCE AND VISUAL DISTURBANCES
Medical Cond Aggravated by Exposure:PREEXISTING RESPIRATORY DISORDERS,
HEART DISEASE
* First Aid Measures *
First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALATION:REMOVE TO
FRESH AIR. PROVIDE CPR/OXYGEN IF NEEDED. EYES:FLUSH WITH WATER FOR
INGESTION:D O NOT INDUCE VOMITING. CALL PHYSICIAN OR POISON CONTROL
CENTER IMMEDIATELY.
* Fire Fighting Measures *
Flash Point Method:TCC
Flash Point:FLAMMABL AEROSOL
Extinguishing Media:WATER FOG, CARBON DIOXIDE, FOAM/DRY CHEMICAL. AVOID
SPREADING ANY BURNING LIQUID WITH WATER SPRAY.
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING AND
NIOSH-APPROVED SELF-CONTAINED BREATHING APPARATUS. COOL
FIRE-EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:SPRAY CANS UNDER PRESSURE. EXTREMELY
FLAMMABLE. EXPLOSION HAZARD EXISTS WHEN SPRAY CANS HEATED. AT
* Accidental Release Measures *
Spill Release Procedures:LEAKING CONTAINERS SHOULD BE PLACED OUTDOORS,
IN AN OPEN CONTAINER, AWAY FROM SOURCES OF IGNITION. ALLOW PRESSURE
TO DISSIPATE. VENTILATE AREA. ABSORB LIQUID WITH NON-FLAMMABLE
ABSORBENT MATERIALS AND PLACE IN CONTAINER FOR DISPOSAL.
Neutralizing Agent:NOT RELEVANT
*Handling and Storage *
Handling and Storage Precautions:STORE SPRAY CANS IN COOL, WELL
VENTILATED AREAS AWAY FROM SOURCES OF IGNITION, SUNLIGHT &
Other Precautions:"EMPTY" CONTAINERS RETAIN RESIDUE AND MAY BE
DANGEROUS. DANGER! EXTREMELY FLAMMABLE. DO NOT INCINERATE. HARMFUL
OR FATAL IF SWALLOWED. MAY CAUSE BLINDNESS. KEEP OUT OF REACH OF
CHILDREN. FOLLOW INSTRU CTIONS ON LABEL.
* Physical/Chemical Properties *
HCC:V3
NRC/State Lic Num:NOT RELEVENT
Spec Gravity:0.7
Viscosity:NOT KNOWN
Solubility in Water:INSOLUBLE
Appearance and Odor:CLEAR WITH SOLVENT-LIKE ODOR
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
SPARKS, OTHER SOURCES OF IGNITION, DIRECT SUNLIGHT
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE
AND FEDERAL REGULATIONS. DO NOT PUNCTURE, INCINERATE SPRAY CANS.
LIQUID CONCENTRATE SHOULD BE DISPOSED OF AS A HAZARDOUS WASTE.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL AND GENERAL VENTILATION NECESSARY TO KEEP AIR
CONCENTRATION BELOW LEVEL OF CONCERN .
Other Protective Equipment:WEAR APRON WHEN CONTACT IS LIKELY,AND CREAM
IF SKIN CONTACT IS LIKELY.
Work Hygienic Practices:REMOVE AND WASH CONTAMINATED CLOTHING BEFORE
REUSE.WASH HANDS.
Supplemental Safety and Health
FIRE FIGHT PROC:PREVENT PRESSURE BUILDUP & EXPLOSION.IF WATER IS
USED,FOG NOZZLES ARE PREFERABLE.
* Product Identification *
* Composition/Information on Ingredients *
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SEE SIGNS AND SYMPTOMS OF
OVEREXPOSURE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES:CAUSES SLIGHT EYE
IRRITATION.SKIN:PROLONGED SKIN CONTACT MAY CAUSE
IRRITATION.INGESTION:N/K .INHALATION:N/K .
Medical Cond Aggravated by Exposure:NONE
* First Aid Measures *
First Aid:EYES:IMMEDIATELY FLUSH EYES WITH PLENTY OF WATER FOR AT LEAST
SOAP AND WATER;IF DRENCHED,REMOVE AND WASH CLOTHING BEFORE
REUSE.INGESTION :IF CONSCIOUS,INDUCE VOMITING AT ONCE BY GIVING TWO
GLASSES OF WATER AND PUTTING FINGER AT BACK OF VICTIM'S THROAT.CALL
PHYSICIAN IMMEDIATELY.INHALATION:REMOVE TO FRESH AIR.
* Fire Fighting Measures *
Flash Point Method:TCC
Lower Limits:N/K
Extinguishing Media:CARBON DIOXIDE,DRY CHEMICAL,WATER FOG.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .WATER SPRAY MAY BE INEFFECTIVE.WATER MAY BE
USED TO COOL CLOSED CONTAINERS TO (SEE SUP DATA)
SEVERAL HOURS MAY RESULT IN THE RELEASE OF ORGANIC ALDEHYDES AND
ALSO ORGANIC ACIDS & CARBON MONOXIDE IN ABSENCE OF OXYGEN.
* Accidental Release Measures *
Spill Release Procedures:DIKE & CONTAIN SPILL WITH INERT MATERIAL &
TRANSFER THE MATERIAL TO CONTAINERS FOR RECOVERY OR DISPOSAL.KEEP
SPILL OUT OF SEWERS & OPEN BODIES OF WATER.FLOORS MAY BE SLIPPERY.
Neutralizing Agent:N/K
*Handling and Storage *
FROM FREEZING,PRODUCT STABILITY MAY BE AFFECTED.
Other Precautions:USE GOOD INDUSTRIAL HYGIENE & SAFETY PRACTICES:AVOID
UNNEC EXPOS;REMOVE MATL FROM SKIN,EYES,CLTHG.MATL CONTAINS WATER &
IS ELEC CONDUCTIVE.DO NOT APPLY W/ ELECTROSTATIC SPRAY EQUIP UNLESS
MODIFIED FOR APPLICATION OF CONDUCTIVE COATINGS.
* Physical/Chemical Properties *
Melt/Freeze Pt:M.P/F.P Text:N/K
Decomp Temp:Decomp Text:N/K
Solubility in Water:N/K
Appearance and Odor:N/K
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:KEEP FROM FREEZING.AVOID KEEPING AT
HOURS MAY RESULT IN RELEASE OF ORGANIC ALDEHYDES,ORG ACIDS & CO IN
ABSENCE OF O*2.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
* Disposal Considerations *
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH
FEDERAL,STATE AND LOCAL REGULATIONS .DO NOT INCINERATE CLOSED
CONTAINERS.
| 1 | eyes_protection_mandatory |
Control Measures
*
Cage: 0Y2E4
Proprietary Ind: Y
*
Contractor Summary
*
Cage: 0Y2E4
*
Ingredients
*
-----------------------------
*
Health Hazards Data
*
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: VAP, SPRAY MIST/SPATTERED MATL CAN BE HARMFUL. IRRIT TO
EYES, SKIN & IF INHALED, TO NOSE & THROAT. EXCESSIVE/PRLNG INHAL CAN
CAUSE HDCH, NAUS/DIZZ. RPTD & PRLNG OCCUP OVEREXP TO SOLVS IS ASSOC
W/PERM BRAIN & NERV DMG. INTENTIONAL ABUSE, MISUSE/OTHER MASSIVE EXPOS
TO SOLVS MAY CAUSE MULTIPLE ORG DMG &/ (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: HLTH HAZ:OR DEATH. SKIN:IRRIT. SEV BURNS.
CAN BE ABSORBED. CAN CAUSE DEFAT & DRYING. INHAL:IRRIT. LUNG INJURY. CNS
DMG. CHEM PNEUM. EYES:IRRIT. CORNEAL INJURY. SEV BURNS. METHANOL, IF
SWALLOWED, CAN C AUSE BLINDNESS. DO NOT WEAR CONTACT LENSES WHEN USING THIS
MATL. INGEST:CAN BE FATAL IF SWALLOWED. ASPIR INTO (SUPDAT)
Medical Cond Aggravated By Exposure: KIDNEYS, LIVER, BLOOD DISORDERS, SKIN,
EYES, STOMACH, INTESTINES, RESPIRATORY, LUNGS.
First Aid: INHAL:REMOVE TO FRESH AIR. RESTORE NORMAL BRTHG. TREAT
SYMPTOMATICALLY. SEE MD. SKIN:WASH THORO W/SOAP & WATER. REMOVE CONTAM
CLTHG. CONSULT MD IF IRRIT PERSISTS. EYES:FLUSH IMMED W/PLENTY OF WATER FO R
ATTN FROM AN OPHTHALMOLOGIST. INGEST:DRINK 1-2 GLASSES OF WATER TO DILUTE.
NEVER GIVE ANYTHING BY MOUTH TO UNCON PERS.
*
Handling and Disposal
*
Spill Release Procedures: REMOVE ALL SOURCES OF IGNIT. AVOID BRTHG VAPS. VENT
AREA. USE ABSORB, INERT, CLEANUP MATLS. (DO NOT USE SAWDUST). REMOVE ABSORB
MATL W/NON-SPARKING TOOLS. PLACE IN SEPARATE CNTNR. KEEP OUT OF SEWERS &
WATERWAYS. IF ENTRY IS THREATENED/OCCURS,
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: PLACE IN SEPARATE, APPROPRIATE, CLOSED CONTAINER I/A/W
ALL APPLICABLE LOCAL, STATE & FEDERAL REGULATIONS. THIS MATERIAL HAS NOT
BEEN TESTED BY TOXICITY CHARACTERISTIC LEACHING PROCEDURE (TCLP). EPA WA STE
Handling And Storage Precautions: KEEP CNTNR CLSD, UPRIGHT WHEN NOT IN USE.
FOR INDUSTRIAL USE ONLY.
Other Precautions: USE CAUTION WHEN POURING. AVOID BREATHING SANDING DUST. DO
NOT WELD OR FLAME CUT ON EMPTY CONTAINERS. DESTROY CONTAMINATED LEATHER &
ABSORBENT SHOES WHICH CANNOT BE DECONTAMINATED.
*
Fire and Explosion Hazard Information
*
Flash Point Method: SCC
Lower Limits: 2%
Extinguishing Media: FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA & FULL PROT EQUIP (FP N).
WATER MAY BE USED TO COOL CLOSED CONTAINERS TO PREVENT PRESSURE
BUILD-UP/EXPLO WHEN EXPOSED TO EXTREME HEAT.
Unusual Fire/Explosion Hazard: FLAMM-CLASS 1B. CLSD CNTNRS MAY EXPLODE WHEN
EXPOS TO EXTREME HEAT & PRESS BUILDUP. MAY PRDCE FLOATING HAZ. ISOLATE
FROM ELEC EQUIP, SPARKS, HEAT & OPEN(SUPDAT)
*
*
Respiratory Protection: WEAR NIOSH APPRVD RESP DESIGNED TO REMOVE COMBINATION
OF PARTICULATES (DUST/SPRAY MIST) & VAP. WHEN BRUSHING, ROLLING/SPREADING
SELECT APPROP NIOSH APPRVD RESP PROT FOR CNDTNS. FOR SPECIFIC CNDTNS, RE FER
TO CURRENT "NIOSH POCKET
Ventilation: IMPLEMENT ADMIN & ENGINEERING CONTROLS TO REDUCE EXPOS.
PROVIDE SUFFICIENT VENT IN VOL & PATTERN TO KEEP AIR
Other Protective Equipment: ANSI APPRVD EYE WASH FOUNTAIN & DELUGE SHOWER (FP
N). DEPENDENT UPON APPLICATION METH WEAR RESIST COVERALLS &
Work Hygienic Practices: WASH THOROUGHLY AFTER HANDLING & BEFORE EATING,
SMOKING OR USING TOILET. LAUNDER CONTAMINATED CLOTHING BEFORE USE.
Supplemental Safety and Health: NOTE:USERS OF "L" VERSION SHOULD CONSULT "LR"
VERSION FOR ADDNL INFO (FP N). EXPLO HAZ:FLAME. VAPS MAY SPREAD LONG DISTS,
CAUSE FLASH FIRE/IGNITE EXPLOSIVELY. EFTS OF OVEREXP:LUNGS CAN DMG LUNGS
& CAU SE CHEM PNEUM. TARGET ORGANS:KIDNEYS, LIVER, BLOOD, LUNGS, HEART,
SKIN, EYES, STOM, CNS, FETAL DEFECTS.
*
Physical/Chemical Properties
*
Vapor Pres: SEE INGS
Vapor Density: HVR/AIR
Evaporation Rate & Reference: 1.4-2 (BUTYL ACETATE=1)
Appearance and Odor: LIQUID; SOLVENT ODOR.
*
Reactivity Data
*
Stability Indicator: YES
Stability Condition To Avoid: HEAT, OPEN FLAME, ARC OR SPARKS. HIGH
TEMPERATURES.
Materials To Avoid: STRONG OXIDIZERS, ACIDS, ALKALIES.
Hazardous Decomposition Products: CO, CO*2, ALDEHYDES, SILICON OXIDE FUMES.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
*
Toxicological Information
*
*
Ecological Information
*
*
*
*
Regulatory Information
*
*
Other Information
*
*
HAZCOM Label
*
Cage: 0Y2E4
Company Name: AMERON PROTECTIVE COATINGS
Label Required IND: Y
Status Code: C
Origination Code: G
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Severe
Fire Hazard: Severe
Reactivity Hazard: None
Hazard And Precautions: FLAMMABLE. ACUTE:IRRITATING TO EYES, SKIN AND IF
INHALED, TO NOSE AND THROAT. INHALATION:HEADACHE, NAUSEA OR DIZZINESS.
POSSIBLE PERMANENT BRAIN AND NERVOUS DAMAGE. MISUSE MAY BE HARMFUL OR FATAL.
LUN G INJURY. SKIN:IRRITATION. SEVERE BURNS, DEFATTING AND DRYING.
EYES:IRRITATION; CORNEAL INJURY, SEVERE BURNS, POSSIBLE BLINDNESS.
INGESTION:CAN BE FATAL. ASPIRATION HAZARD - LUNG DAMAGE AND CHEMICAL P
NEUMONITIS. CHRONIC:NONE LISTED BY MANUFACTURER. TARGET ORGANS:KIDNEYS,
LIVER, BLOOD, LUNGS, HEART, SKIN, EYES, STOMACH, CENTRAL NERVOUS SYSTEM,
FETAL DEFECTS.
*
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NORMALLY NOT REQUIRED. RECOMMENDED IF FUMING OR
MISTING. USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOC EXHST: RECOMMENDED TO CAPTURE HOT FUMES. MECH:
RECOMMENDED IF FUMING OR MISTING.
Other Protective Equipment:NORMALLY NOT REQUIRED.
Work Hygienic Practices:WASH THORO AFTER HNDLG. WASH HANDS BEFORE
EATING OR DRINKING. DO NOT WEAR CONTAMD CLTHG. REMOVE & LAUNDER
BEFORE REUSE.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
* Product Identification *
Product ID:A-8/0
* Composition/Information on Ingredients *
Ingred Name:MINERAL OIL,PETROLEUM DISTILLATES, HYDROTREATED(SEVERE)
HEAVY NAPHTHENIC: (PETROLEUM LUBRICATING OIL BASE STOCK).
OSHA PEL:5 MG/M3 (MFR)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PLNG/RPTD SKIN CONTACT TENDS TO REMOVE
SKIN OILS & MAY CAUSE SKIN IRRITATION EXPOSURE TO FUMES OR MISTS.
MAY CAUSE MUCOUS MEMBRANE IRRITATION.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:MILD IRRITATION OF SKIN & MUCOUS MEMBRANE.
Medical Cond Aggravated by Exposure:
* First Aid Measures *
First Aid:SKIN: WIPE OFF & WASH W/SOAP & WATER. EYE: FLUSH W/COPIOUS
AMOUNTS OF WATER & SEE MD. INHAL: REMOVE FROM EXPOSURE TO FRESH
AIR. INGEST: ADMINISTER WATER & SEEK MED AID. DO NOT INDUCE
VOMITING.
* Fire Fighting Measures *
Flash Point Method:COC
Lower Limits:1%
Upper Limits:6%
Extinguishing Media:CO*2, DRY CHEMICAL, FOAM & WATER FOG (CAREFULLY TO
PREVENT FROTHING).
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT.
Unusual Fire/Explosion Hazard:NONE.
* Accidental Release Measures *
Spill Release Procedures:STOP FLOW. ELIMINATE IGNITION SOURCE. RECOVER
FREE PRODUCT. ADD ABSORBENT MATERIAL SUCH AS CLAY TO SPILL AREA.
SWEEP OR SCRAPE UP.
Neutralizing Agent:
*Handling and Storage *
Handling and Storage Precautions:KEEP CNTRS CLOSED. HANDLE & STORE
USING METHODS GENERALLY ADVOCATED FOR PETROLEUM PRODS. DO NOT
STORE/MIX W/OXIDIZING MATLS. AVOID EXCESS HEAT/FLAMES.
Other Precautions:AVOID REPEATED CONTACT WITH SKIN. AVOID CONTACT WITH
EYES & INHALATION OF FUMES, VAPORS OR MISTS. DO NOT INGEST.
* Physical/Chemical Properties *
Solubility in Water:NEGLIGIBLE
Appearance and Odor:OPAQUE AMBER SEMI-FLUID GREASE W/MILD PETROLEUM
ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:EXCESSIVE HEAT & OPEN FLAMES.
Hazardous Decomposition Products:OXIDES OF CARBON MAY FORM ON
INCOMPLETE COMBUSTION.
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF AS LOCAL, STATE & FEDERAL LAWS PERMIT
FOR PETROLEUM HYDROCARBONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:USE A NIOSH APPROVED RESPIRATOR
Ventilation:LOCAL EXHAUST: RECOMMENDED. MECHANICAL (GENERAL):
ACCEPTABLE.
Other Protective Equipment:PROTECTIVE LAB COAT, EYE WASH & SAFETY
SHOWERS
Work Hygienic Practices:WASH THOROUGHLY AFTER USE.
Supplemental Safety and Health
* Product Identification *
Product ID:BPI MOLECULAR BPI UV BROWN PLUS
* Composition/Information on Ingredients *
Ingred Name:ACETAMIDE, N-(4-((2-HYDROXY-5-METHYLPHENYL)AZO)PHENYL)
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHALATION: SLIGHT IRRITATION.
EYES/SKIN: IRRITATION. SENSITIZOR, MAY CAUSE ALLERGIC REACTION.
INGESTION: MAY BE TOXIC. 1,4-DIAMINOANTHRAQUINONE MAY BE
MULTAGNETE, POSITIVE AMES TEST.
Explanation of Carcinogenicity:SEE INGREDIENTS.
Effects of Overexposure:IRRITATION, REDNESS
Medical Cond Aggravated by Exposure:EXISTING SKIN CONDITIONS.
* First Aid Measures *
First Aid:INHALATION: MOVE TO FRESH AIR. EYES/SKIN: FLUSH WELL W/WATER
* Fire Fighting Measures *
Extinguishing Media:WATER FOG, DRY CHEMICAL, CO2, FOAM
Fire Fighting Procedures:WEAR SELF CONTAINED BREATHING APPARATUS
W/PROTECTIVE CLOTHING TO AVOID PERSONAL CONTACT.
* Accidental Release Measures *
MATERIAL. PLACE IN CLOSED CONTAINER FOR PROPER WASTE DISPOSAL. FOR
LARGE: WEAR A NIOSH AP PROVED RESPIRATOR.
*Handling and Storage *
Handling and Storage Precautions:USE ONLY W/APPROPRIATE EQUIPMENT.
DON'T USE A HOT PLATE/OPEN FLAME. KEEP CONTAINER CLOSED WHEN NOT IN
USE. WORK IN WELL VENTILATED AREA.
Other Precautions:AVOID EYE & SKIN CONTACT. DON'T INGEST.
* Physical/Chemical Properties *
Spec Gravity: 1
Evaporation Rate & Reference:(WATER=1): 1
Solubility in Water:MISCIBLE
Appearance and Odor:COLORED LIQUID W/SLIGHT ODOR.
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
OXIDIZING & REDUCING AGENTS, STRONG ACIDS, STRONG BASES, HOT PLATE.
Stability Condition to Avoid:OPEN FLAME
Hazardous Decomposition Products:OXIDES OF CARBON, NITROGEN & SULPHUR
* Disposal Considerations *
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
* Exposure Controls/Personal Protection *
Respiratory Protection:NIOSH-APPROVED DUST RESPIRATOR IN DUSTY
SITUATIONS.
Ventilation:ADEQUATE
Other Protective Equipment:SAFETY SHOWER AND EYE WASH FOUNTAIN SHOULD
BE LOCATED NEARBY. WEAR APPROPRIATE PROTECTIVE CLOTHING FOR RISK OF
EXPOSURE.
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES.
Supplemental Safety and Health
* Product Identification *
Product ID:DESICCANT,ACTIVATED
Preparer's Name:CHARLES A. EISENHARD
* Composition/Information on Ingredients *
Ingred Name:DESICCANT,ACTIVATED
Other REC Limits:NONE RECOMMENDED
* Hazards Identification *
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYES, SKIN, RESPIRATORY
TRACT. ACUTE- IRRITATION OF EYES, NOSE AND THROAT BY DUST. MAY
CAUSE SKIN IRRITATION OR BURN IF WET. CHRONIC- UNKNOWN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION OF EYES, SKIN, NOSE AND THROAT BY
DUST
* First Aid Measures *
First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALED:REMOVE TO FRESH
MINUTES, HOLDING EYELIDS OPEN. SKIN:WASH WITH SOAP & WATER.
ORAL:GET MEDIC AL ATTENTION.
* Fire Fighting Measures *
Flash Point:NONE
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, FOAM OR DRY CHEMICAL
FOR SURROUNDING FIRE. USE WATER SPRAY TO COOL FIRE EXPOSED
CONTAINERS.
Fire Fighting Procedures:AS WITH ANY FIRE, WEAR PROTECTIVE CLOTHING AND
NIOSH-APPROVED SELF-CONTAINED BREATHING APPARATUS TO AVOID
INHALATION OF HAZARDOUS DECOMPOSTION PRODUCTS.
Unusual Fire/Explosion Hazard:NONE KNOWN
* Accidental Release Measures *
Spill Release Procedures:SWEEP UP AND PLACE IN A DISPOSAL CONTAINER.
FLUSH AREA WITH WATER. AVOID RAISING DUST. VENTILATE AREA.
Neutralizing Agent:NOT RELEVENT
*Handling and Storage *
Handling and Storage Precautions:OPEN CONTAINER SLOWLY TO AVOID DUST.
DO NOT GET IN EYES. AVOID BREATHING DUST & PROLONGED CONTACT WITH
SKIN. KEEP CONTAINER CLOSED. DO NOT INGEST.
Other Precautions:WASH THOROUGHLY AFTER HANDLING. KEEP OUT OF REACH OF
CHILDREN.
* Physical/Chemical Properties *
HCC:T6
NRC/State Lic Num:NOT RELEVENT
Evaporation Rate & Reference:NOT RELEVENT
Appearance and Odor:ODORLESS
* Stability and Reactivity Data *
Stability Indicator/Materials to Avoid:YES
SUDDEN CONTACT WITH HIGH CONCENTRATIONS OF CHEMICALS HAVING HIGH HEATS
OF ADSORPTION SUCH AS OLEFINS, HCL, ETC.
Stability Condition to Avoid:NONE KNOWN
Hazardous Decomposition Products:NONE KNOWN
* Disposal Considerations *
Waste Disposal Methods:BURY IN LANDFILL. OBSERVE ALL LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
Subsets and Splits